@DETROIT. · For vehicles equipped with Detroit Assurance, parameter PGR043 should be set to O (zero) disable. Is parameter PGR043 set to disable? a. Yes; replace the CPC. Verify

06 13-16

1 06 13-16

@DETROIT.

Service Information Bulletin

SUBJECT DATE

SPN 1590 (CPC) (GHG17) June 2016

Additions, Revisions, or Updates

Publication Number/ Title Platform Section Title Change

SPN 1590/FMI 9 -GHG17 GHG17

DDC-SVC-MAN-0193 Medium New DDS and DDS diagnostic procedures.

Duty SPN 1590/FMI 19 -

GHG17

SPN 1590/FMI 9 -

GHG17 DD GHG17 DDC-SVC-MAN-0191 Removed GHG14 reference and added new steps.

Platform SPN 1590/FMI 19 -

GHG17

DiagnosticLink users: Please update the troubleshooting guides in DiagnosticLink with this newest version. To update the tool troubleshooting guide, open DiagnosticLink and from the Help - Troubleshooting Guides menu, select the appropriate troubleshooting manual, then click Update.

~DETROIT. \g DEMAND PERFORMANCE~

13400 Outer Drive, West, Detroit, Michigan 48239-4001 Telephone: 313-592-5000 www.demanddetroit.com

All information subject to change without notice. 06 13-16 Copyright© 2016 DETROIT DIESEL CORPORATION

3

2 SPN 1590/FMI 9 - GHG17

2 SPN 1590/FMI 9 - GHG17

Adaptive Cruise Control Message Not Received

Table 1.

SPN 1590/FMI 9

Description Adaptive Cruise Control Message Not Received

Monitored Parameter PGR043 Adaptive Cruise Control Enable

Typical Enabling Conditions Key On, CPC Online, CAN Network Online, Adaptive Cruise Control System Equipped, 1 O Seconds After the Engine Has Been Cranked

Monitor Sequence None

Execution Frequency Continuous When Enabling Conditions Met

Typical Duration Two seconds

Dash Lamps None

Engine Reaction None

Verification Engine Running For One Minute

WARNING: ENGINE EXHAUST

To avoid injury from inhaling engine exhaust, always operate the engine in a well-ventilated area. Engine exhaust is toxic.

4

1. Connect DiagnosticLink ®.

2. Tum the ignition ON (key ON, engine OFF). 3. Verify that the vehicle is equipped with an Adaptive Cruise Control system. Is the vehicle equipped with Adaptive

Cruise?

a. Yes; Go to step 5. b. No; Go to step 4.

4. Verify that the" Adaptive Cruise Control Enable" parameter PGR043 is disabled; refer to the Application and Installation (A&I) manual. Is parameter PGR043 disabled?

a. Yes; replace the Common Powertrain Controller (CPC). Verify repair. b. No; change the "Adaptive Cruise Control Enable" parameter PGR043 to disabled. Verify repair.

5. Is the vehicle equipped with Detroit Assurance?


6. For vehicles equipped with Detroit Assurance, parameter PGR043 should be set to O (zero) disable. Is parameter PGR043 set to disable?

a. Yes; replace the CPC. Verify repair. b. No; change parameter PGR043 to disable. Verify repair.

All information subject to change without notice. Copyright© 2016 DETROIT DIESEL CORPORATION 06 13-16

06 13-16

! Param1tu

'.t" ·~J PGR03l Engine Conftg:urJ1t1on

:•: 'i) PGR031 Vthid• Par1mtttr1 ID :.t. t,): PGP.032 Cool•nt levc:I Senior

<- l PG~3~ Oigit•I O•tputs ;;J PGR037 f•ult Man•gemc:nt ;.:J PG~ 'Vehicle S.:,eed Governor

~f f.cJ PGmJ.I V-1icl• Min :1:. ·~) PGFtl'.MO Anti T•mp1:ring :.t, ·i. ·; PGRO(l Cornpon,tl'lt ID

--•- "t) PGll!-42 On PGIIOal3Ace ACC a<:upt ~t-,'-':rne Time

Fut ACC Gov Engint: br•ke mode Manu,I Cruise: En1blie ACQ Tx Mod• S.ltction

PGIIOal( SynCiov ~) PGFOlfi m1u-t P-1:rttcubitt F,ittr

-_.: ;J PGlll,7 Ag a: 'i J PGR0-18 Pt<onl

PGF'l:M9 Rt"!.tC\l'td

PGFlllSOHDMShn ·•· ~J PGIV.51 ldle Volume

/"',.

DiagnosticUnk

V1lu« Units. M... M11:11L. O•criptton

nOf'lt

en,bte diuble

tJ43,W3} H<w ACC (iov Engi~e b••ke mode ll)O,o'.MJ "4•nu•I Cruis, fo•ble(vi• double toggle) •fter Act system f•olun, (O.U,IJ)S.) CPC to nnd ACCl mc.s:sag1: to support ltgacy produds

mm••f,.' .,".,<.,Ot:Dl'\t;.::i,c: ... ,i:,f .... ! .. ~, _____________________________________________________ T_:: 0 P1r1metc:rs we(e :i:ut(Mully read from the device.

d500216

Figure 1. Adaptive Cruise Control

All information subject to change without notice_ 06 13-16 Copyright© 2016 DETROIT DIESEL CORPORATION

5

2 SPN 1590/FMI 9 - GHG17

6

d500215

Figure 2. Adaptive Cruise Control Options 7. Does the display on the Adaptive Cruise Control module illuminate when the ignition is in the ON position?

a. Yes; refer to the Adaptive Cruise Control maintenance manual and Original Equipment Manufacturer (OEM) for further diagnostic information.

b. No; verify power and ground to the Adaptive Cruise Control module. Refer to Original Equipment Manufacturer (OEM) for wiring information.


06 13-16

3 SPN 1590/FMI 19 - GHG17

Adaptive Cruise Control - General Error

Table 2.

SPN 1590/FMI 19

Description Adaptive Cruise Control Message not Received or Signal Error

Monitored Parameter Adaptive Cruise Control

Typical Enabling Conditions Always On



Typical Duration Two Seconds

Dash Lamps None


Verification Key Cycle - Ignition ON

Check as follows:



NOTE: This fault code may set if driver does not wait for gauge sweep after turning the ignition on.

1. Check for multiple codes. Is Common Powertrain Controller (CPC) SPN 168/FMI 0/14/18 (battery voltage) also present?

a. Yes; troubleshoot those faults first. b. No; Go to step 2.

2. Verify that the vehicle is equipped with an Adaptive Cruise Control system. Is the vehicle equipped with Adaptive Cruise?


3. Verify that the "Adaptive Cruise Control Enable" parameter PGR043 is disabled; refer to the Application and Installation (A&I) manual. Is parameter PGR043 disabled?

a. Yes; replace the CPC. Verify repair. b. No; change the "Adaptive Cruise Control Enable" parameter PGR043 to disabled. Verify repair.






7

3 SPN 1590/FMI 19 - GHG17

! Param1tu











/"',.

DiagnosticUnk


nOf'lt

en,bte diuble




8

d500216

All information subject to change without notice_ Copyright© 2016 DETROIT DIESEL CORPORATION 06 13-16

06 13-16

d500215





9

4 SPN 1590/FMI 9 - GHG17

4 SPN 1590/FMI 9 - GHG17

Adaptive Cruise Control Message Not Received

Table 3.

SPN 1590/FMI 9

Description Adaptive Cruise Control Message Not Received

Monitored Parameter PGR043 Adaptive Cruise Control Enable

Typical Enabling Conditions Key On, CPC Online, CAN Network Online, Adaptive Cruise Control System Equipped, 1 O Seconds After the Engine Has Been Cranked



Typical Duration Two seconds

Dash Lamps None


Verification Engine Running For One Minute



10

1. Connect DiagnosticLink ®.

2. Tum the ignition ON (key ON, engine OFF). 3. Verify that the vehicle is equipped with an Adaptive Cruise Control system. Is the vehicle equipped with Adaptive

Cruise?


4. Verify that the" Adaptive Cruise Control Enable" parameter PGR043 is disabled; refer to the Application and Installation (A&I) manual. Is parameter PGR043 disabled?

a. Yes; replace the Common Powertrain Controller (CPC). Verify repair. b. No; change the "Adaptive Cruise Control Enable" parameter PGR043 to disabled. Verify repair.






! Param1tu











06 13-16

/"',.

DiagnosticUnk


nOf'lt

en,bte diuble



d500216


All information subject to change without notice_ 11 06 13-16 Copyright© 2016 DETROIT DIESEL CORPORATION

4 SPN 1590/FMI 9 - GHG17

12

d500215





06 13-16

5 SPN 1590/FMI 19 - GHG17

Adaptive Cruise Control - General Error

Table 4.

SPN 1590/FMI 19

Description Adaptive Cruise Control Message not Received or Signal Error

Monitored Parameter Adaptive Cruise Control

Typical Enabling Conditions Always On



Typical Duration Two Seconds

Dash Lamps None


Verification Key Cycle - Ignition ON

Check as follows:



NOTE: This fault code may set if driver does not wait for gauge sweep after turning the ignition on.

1. Check for multiple codes. Is Common Powertrain Controller (CPC) SPN 168/FMI 0/14/18 (battery voltage) also present?

a. Yes; troubleshoot those faults first. b. No; Go to step 2.

2. Verify that the vehicle is equipped with an Adaptive Cruise Control system. Is the vehicle equipped with Adaptive Cruise?


3. Verify that the "Adaptive Cruise Control Enable" parameter PGR043 is disabled; refer to the Application and Installation (A&I) manual. Is parameter PGR043 disabled?

a. Yes; replace the CPC. Verify repair. b. No; change the "Adaptive Cruise Control Enable" parameter PGR043 to disabled. Verify repair.






13

5 SPN 1590/FMI 19 - GHG17

! Param1tu








-_.: ;J PGlll,7 Ag

a: 'i J PGR0-18 Pt<onl PGF'l:M9 Rt"!.tC\l'td


/"',.

DiagnosticUnk


nOf'lt

en,bte diuble




14

d500216

All information subject to change without notice_ Copyright© 2016 DETROIT DIESEL CORPORATION 06 13-16

06 13-16

d500215





15

Documents

@DETROIT. · For vehicles equipped with Detroit Assurance, parameter PGR043 should be set to O (zero) disable. Is parameter PGR043 set to disable? a. Yes; replace the CPC. Verify