Unit 10BBarrowside Business ParkSleaty RoadGraiguecullenCarlow

Focus Your Energy E: info@hybrid.ie W: www.hybrid.ie

HYbrid Energy Station HES 4

Application:• Site loads up to 400 A (@48 V DC)• Recommended load factor is 50% for optimum CapEx / OpEx balance.• Increased fuel e� ciency can be achieved by reducing load factor further• There is NO MINIMUM LOAD

High Security Enclosure: • 1956mm x 1500mm x 2290m (w x d x h) • ‘Corten’ steel panels • Structural steel 3–6mm thickness • Painted � nish • 3 x primer, top coat • Total � lm thickness 160 microns • Minimum gloss level 80% • Two separate equipment compartments: engine compartment and battery compartment • Engine compartment: • 1 door and 1 service hatch • Forced ventilation • Acoustic insulation 65 dB @ 1m • 700 litre bunded fuel tank • Electrical compartment: • 2 doors • Sealed and insulated• Universal battery mounting system • Temperature controlled • External lockable fuel � ll point • Fork lift pockets • Low power LED internal and external lighting*

Inverter* :• Single or 3 phase• 230/400 V AC, 50/60 Hz or other to suit site load• State solid pure sin wave technology• 1-10 kVA, scalable• Overload protection• Grid – tie inverter/charger with grid priority setting*

Battery: • Lithium Ion*• Advanced rare earth chemistry• Light weight and compact• Low maintenance, sealed for life construction• Up to 2,000ah capacity• 15 x 3.2 volt cells = 48V DC• Cycle life 4 x pure lead• Very high charge and discharge capabilityOr:• CLS pure lead series• Absorbent gas mat (AGM) technology• Pure lead grid for high power density• Low maintenance, sealed for life construction• Up to 800 aH capacity (10h@25˚C)• 24 x 2 volt cells = 48V DC• Excellent discharge characteristic

Patent Pending GB 1216302.8

Discharge characteristic [25°C]

*Indicates optional equipment

Focus Your Energy

Engine:• Isuzu 3CA1• EPA Tier3, Tier 4 interim compliant• 4 stroke compression ignition• Diesel fuel• 3 cylinder in-line, OHV• Liquid cooled• 0.9 litre displacement• Low fuel consumption, over wide range of speeds

Or:

• Isuzu 4LE1*• EPA Tier3, Tier 4 interim compliant• 4 stroke compression ignition• Diesel fuel• 4 cylinder in-line, OHV• Liquid cooled• 2.2 litre displacement• Low fuel consumption

Alternator: • Permanent magnet type• Operating speed 2,200 – 2,800 RPM• Rated power up to 20kW*• Thermal protection• Overcurrent protection• Overspeed protection• Simple construction; 1 moving part, no bearings, or sliding contacts

Battery Management System*: • Up to 180 cells• 900 V max• Cell balancing to within 10 mV• Charge and discharge enable supervision and control• State of charge, health, current, temperature, cell resistance monitoring• Multiple strings of cells in parallel for battery redundancy*

Control System: • Microprocessor controlled• Fully automatic, autonomous operation• Remote monitoring, diagnosis and control• Historical data trending• Monitors and controls all major operating parameters of the HYbrid system• Expandable to monitor clients equipment or relay signals to client’s system*

*Indicates optional equipment

Unit 10BBarrowside Business ParkSleaty RoadGraiguecullenCarlow

Focus Your Energy E: info@hybrid.ie W: www.hybrid.ie

HYbrid Energy Station HES 4Air Conditioning*:• Free air cooling unit, Thermosyphon• DC air conditioner• Hybrid free air cooling / DC air conditioner• Up to 3,000 Watts cooling @ 48 V DC• R134a refrigerant• Quiet (65 dB @ 1.5m)• Variable speed compressor and fans• Microchannel heat exchangers• High efficency

Due to HYbrid Energy’s policy of continuous improvement, these specifications are subject to change without notice

Remote Monitoring:• On-board GPRS modem• Full remote control and monitoring• SMS alerts• Web based interface• Historical data recording• Alarm list and fault reset• Fleet status at-a-glance

Unit 10BBarrowside Business ParkSleaty RoadGraiguecullenCarlow

Ambient Temperature Power ConsumptionInternal Temp 30 25 300 55 450

Internal Temp 35 25 450 55 540

Ambient Temperature Power ConsumptionInternal Temp 30 25 1100 55 625

Internal Temp 35 25 1230 55 725

Focus Your Energy E: info@hybrid.ie W: www.hybrid.ie

HYbrid Energy Station HES 4

Datasheet issued 29 April 2013*Indicates optional equipment

Unit 10BBarrowside Business ParkSleaty RoadGraiguecullenCarlow

System

Fuel

Lube oil

Electrical System

Alternator

Enclosure

Controls

Battery

Feature

700 litre tankFuel puri� er

Secondary Racor turbine � lter*Water in fuel sensor*Lockable � ller capBypass oil � lter with evaporation chamber

400 A ratingInverterSolar Array*

400 A rating*PMGAll steel constructionForklift pockets, twist locksHigh quality paint � nishGood access, lighting*Separate electrical and engine compartmentsGPRS communication

FlexibleProtection functions

Sealed lead acidLithium Ion*

Bene� t

• Up to 3 months between refuelling• Removes large particles and water from the fuel supply before it enters the engine fuel system• Increases fuel � lter life where there is heavy fuel contamination

• Shuts down engine safely if fuel is contaminated with water• Reduces fuel theft• Removes contaminants and acidic by-products of combustion• Increases oil life. Ideal for areas with poor fuel quality• Service interval up to 1,000 hours• Peak loads of 400 A possible• Site legacy AC loads can be supplied as well as DC• Increase fuel e� ciency by using solar energy to charge the battery pack and power the site load during the day• Max continuous DC load possible, 400• Robust, simple and reliable. High e� ciency• Secure and vandal resistant• Easy to handle• Life expectancy >15 years in tough environments• Reduced maintenance cost• Di± erent operating environments to suit the equipment therein

• Web based remote monitoring• Remote fault diagnosis and repair• Increased availability• Con� gurable to client’s requirements*• Monitors HES performance and protects the equipment from damage in the case of a malfunction• Maintenance free• Increased fuel e� ciency• Longer life• Maintenance free• Reduced OpEx