Marine Grade 500W 12/24

Volt Wind Generator

er Manual

SAVE THESE INSTRUCTIONS

WARNING: Read and understand all instructions, warnings, and cautions before using thisproduct. Failure to follow the instructions, warnings, and cautions may result in serious personal injury and/or property damage.

Item # 70 01

4 20t

Page of 6

Generator

Generator

For your ease write the serial number of your wind generator on the front of this manual. Store your manual and receipt together. you will need this information in the event of a warranty claim

enerator

1. PRECAUTIONS1.1 MECHANICAL HAZARDS1.2 ELECTRICAL HAZARDS1.3 INSTALLATION PRECAUTIONS1.4 OPERATION PRECAUTIONS

2. PACKAGE CONTENTS

3.WIRING AND INSTALLATION PROCEDURES3.1 SYSTEM WIRING DIAGRAMS

4.LOCATION SELECTION

5. TOWER

6.1 SINGLE WIND GENERATOR6.2 CONTROLLER WIRING 6.3 INSTALLATION OPERATION6.4 ATTACHING TO POLE 6.5 STEP-BY-STEP INSTRUCTION

7. ELEVATION

8. SPECIFICATIONS

9. WARRANTY

4

6

7

9001

5

5

8

6

33333

Generator

generatorGENERATOR

w generator w g

There are two wires(black = Negative (-) Red = positive (+)), ensure that polaritymaintained.

Page 3 of 6

N

The wind generator is equipped with sophisticated electronics designed to provide protection from high surge electrical dangers. The internal electronics of the wind generator prevents open circuit voltage from rising above 20 volts for 12-volt systems. please noted that the inherent personal dangers from electrical current still exist, therefore caution should always be used when connecting this and other electrical devices.

e

onne t t e o er ea ro t e atter an t e t e n enerator o t t ea

to et er to to o t e a e ro roat n

t e ear n n ot t e enerator a an t e enerator rotor re rea ro ate o r o o erat on n nor a n ee a ro ate

e ore t e are r nn n at ea e en r n t rea n er o t e enerator o erat on t a ear

Page 4 of 6

w generator

generator

up

Page 5 of 6

w g

w g

w g

w g w g

Page 6 of 6

w g

w g

Page 7 of 6

5. TOWER

Page 8 of 6

enerator

Page 9 of 6

Do not make a mistake in connecting the wires. Positive must be connected to positive, and negative connected to negative throughout connections from generator to power meter box, to battery.

When the wind generator green light is on or flashing, it is normal charging. please connect with power meter box in any time, without power meter box positive and negative direct short circuit easily damaged internal controller in wind condition, the warranty will not covered. the power meter box main function is display and brake the wind generator, the MPPT controller is located in the wind generator body.

Page 0 of 6

contact between the tower and yaw is through the rubber pad, which will

While attaching the wind generator to the tower, be careful not to pinch the

Page 1 of 6

6.5 S T e o o n te te n ta at on ro e re ro es o t an o t ne o t e n generator n ta at on ro e T on o ate re eren e o on e e a an o t ne r n n ta at on Re er to t e a ro r ate e t on or rt er eta Installation instructions assume a basic familiarity and comfort in working with DC voltage electrical wiring and batteries. If you are not knowledgeable on, or comfortable, working with DC voltage and electrical wiring please consult with a trained electrician or wind generator technician.

Warranty does not cover any damage due to improper installation, or faulty tower construction.

w g

w g

M6 Nut(6)

Page 2 of 6

Page 3 of 6

Page 4 of 6

1 B . A .. T S .

Page 5 of 6

w g

w g

w g

70501 G Generator

n

an a o ta e

at n ee

art nterna T ontro er

ar on er o o te

a t a n t ar ne o er oat n

n n e e e

O E

ROTOR A ETER

E G T

TART N EE

O TAGE

A N EE

RATE O ER

ONTRO ER

A E

O E EN ON

O ATERIA

PleasecontactNaturePowerProductstoacquiremoreinformation:

1-800-588-0590info@naturepowerproducts.com

www.naturepowerproducts.com

Made in China

Page 6 of 6

Nat re

Nat re

ate on t an a Nat re o er

An o at on to t e n enerator o t e arrant an

T n enerator t e n ta e an o erate n a or an e to t e

Damage from lighting.

Damage from improper installation (Including poor tower design and inverted hanging). Damage from improper wiring.

9. Warranty policy proof of purchase is requires(Receipts)Nature Power are warranted for a 2 year period, Against defective parts or manufactures workmanship.