Embed Size (px)
Citation preview
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Application• Combination and non-combination motor starters are used in
areas where hazardous materials are handled or stored. • These units provide disconnecting means, undervoltage
protection, circuit protection, and motor running protection.
Features• Copperfree cast aluminum.• Precision machined flame path between box and cover.• Bolt on slotted mounting feet.• Stainless steel, captive Quad-Lead® cover bolts (disengage in
1-1/2 turns).• External stainless steel breaker operating handle.• Ground lug package and installation instructions for termination
of ground wire enclosed.• Four point control terminal block, NEMA 1B with wire markers.• Breaker operators can be locked in the ON or OFF position
(combination starters only).• Four plugged 3/4” NPSM outlets drilled and tapped for control
devices.• Standard outlets top and bottom.• Plugged 1/2” outlets top and bottom for optional breather/
drain.• Components are mounted on a galvanized steel removable
pan.• Enclosures are designed to accept Cutler-Hammer ✢, or Square
D motor starters/circuit breakers. For other manufacturers, contact your local representative.
• O-ring gasket insures watertight integrity.
Standard Materials• Bodies and covers: copperfree (4/10 of 1%) aluminum• Block hinges, cover bolts, handle, breaker and operator shafts:
stainless steel• O-ring: neoprene
Standard Finish• Corrosion resistant gray powder coat epoxy inside and out
Options• See modifications page.
NEC Certifications and Compliances• ANSI/UL Standards: UL 508, UL 50, UL 1203• CSA Standards: C22.2 No. 0-10, C22.2 No. 14-10,
C22.2 No. 25-1996, C22.2 No. 30-M1986 and C22.2 No. 94-M91
• cCSAus Certified: 2561837
✢ Cutler-Hammer is a registered trademark of Eaton Corporation. Square D is a registered trademark of Schneider Electric.
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC EXPLOSIONPROOF MOTOR STARTERS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
281
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Catalog Numbering GuideExample: The part number below depicts an Appleton, Class I, Division I, Groups B, C and D, NEMA Size 1, Bolted type, Combination Full Voltage Nonreversing Motor Starter operating at 480 Vac, Cutler-Hammer ✢ starter w/120 Vac control voltage, and a Cutler-Hammer 7A MCP. If a breaker is not required, omit last two characters.
AE 1 B B 4 W 1 C 2 ▲
NEC/CEC Certified AE Series
Starter Function: A - FVNR (ATL) B - Combination FVNRM - Lighting Contactor
(3- thru 12-pole) N - Combination
Lighting Contactor (3- thru 12-pole)
Optional Starter Function : C - FVRD - Combination FVRE - 2S1W F - Comb. 2S1WG - 2S2WH - Combination 2S2WJ - Contactor (3 pole)K - Combination
Contactor (3-pole)
Control Voltage (120 V coil standard):1 - 120 Vac2 - 240 Vac3 - 380 Vac4 - 480 Vac6 - 600 Vac8 - 480 V Coil/120 V
Control9 - 208 Vac0 - 277 Vac
Suffix for Other Options/Features:See Modifications
NEMA Size:012345
Operating Voltage:1 - 120 Vac2 - 240 Vac3 - 380 Vac4 - 480 Vac6 - 600 Vac9 - 208 Vac
Breaker Manufacturer: C - Cutler-HammerS - Square D
Enclosure Type:B Series
Starter Manufacturer: W - Standard; Eaton/
Cutler-Hammer (A200)
C - Freedom (AN16) Bi Metal; Eaton/Cutler-Hammer and
A - Freedom (AN19) Electronic; Eaton/ Cutler-Hammer
S - Square D
MCP or Breaker Trip:MCP
1 - 3 Amp2 - 7 Amp3 - 15 Amp4 - 30 Amp5 - 50 Amp6 - 70 Amp7 - 100 Amp8 - 150 Amp9 - 250 Amp0 - 400 Amp
Breaker Trip (Thermal Mag):A - 15 AmpB - 20 AmpC - 25 AmpD - 30 AmpE - 35 AmpF - 40 Amp G - 50 AmpH - 60 AmpJ - 70 Amp K - 80 AmpM - 90 AmpN - 100 AmpP - 125 AmpQ - 150 AmpR - 175 AmpS - 200 AmpT - 225 AmpU - 250 AmpV - 300 AmpW - 350 AmpX - 400 Amp
Standard starter is manufactured by Square D; electrically operated, electrically held. Optional starter manufacture is ASCO; electrically operated, mechanically held. Contact your local sales representative for details.
Contact your local sales representative for details. Contact your local sales representative for additional UL Classified starters (Allen Bradley 509 and Vacuum, Sprecher and Schuh, Siemens, GE, and Cutler
Hammer ITT Softstart and V200 Vacuum).
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
EXP
LOSI
ONPR
OOF
MOTO
R ST
ARTE
RS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
282
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Empty Enclosure
NEMA Size Catalog Number ▲
Approximate Weightkg (lb)
Standard Conduit (Inches)
Mounting Hardware Set Catalog Number
Full Voltage Nonreversing Enclosure Only
0 AE0BA 36 (80)
1-1/2
AMH7
1 AE1BA 36 (80)
2 AE2BA 39 (85)
3 AE3BA 64 (140) 2
4 AE4BA 64 (140) 2-1/2
5 AE5BA 227 (500) 4 AMH8
Dimensions in Millimeters (Inches) — Starter Only
Enclosure Layout for Size 0, 1 and 2 — Starter Only
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 3 — Starter Only
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
Left Side View Front View Top View Bottom View
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see AEB Series Motor Starters Modifications.
CONTROLS: NEC/CEC EXPLOSIONPROOF MOTOR STARTERS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
283
Dimensions in Millimeters (Inches) — Starter Only
Enclosure Layout for Size 4 — Starter Only
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56) RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 5 — Starter Only C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
Left Side View Front View Top View Bottom View
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
EXP
LOSI
ONPR
OOF
MOTO
R ST
ARTE
RS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
284
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Empty Enclosure
NEMA Size Catalog Number ▲
Approximate Weightkg (lb)
Standard Conduit (Inches)
Mounting Hardware Set Catalog Number
Combination Full Voltage Nonreversing Enclosure Only
0 AE0BB 36 (80)
1-1/2
AMH7
1 AE1BB 36 (80)
2 AE2BB 39 (85)
3 AE3BB 64 (140)2-1/2
4 AE4BB 64 (140)
5 AE5BB 227 (500) 4 AMH8
Dimensions in Millimeters (Inches) — Combination
Enclosure Layout for Size 0, 1 and 2 — Combination
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 3 and 4 — Combination
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
Left Side View Front View Top View Bottom View
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see AEB Series Motor Starters Modifications.
CONTROLS: NEC/CEC EXPLOSIONPROOF MOTOR STARTERS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
285
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Dimensions in Millimeters (Inches) — Combination
Enclosure Layout for Size 5 — Combination C L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
Left Side View Front View Top View Bottom View
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
EXP
LOSI
ONPR
OOF
MOTO
R ST
ARTE
RS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
286
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Full Voltage Motor Starter — Nonreversing — 3-Phase, 60 Hertz, 120 V Coil
Line Voltage
NEMA Size
Maximum Horsepower
Amp Trip Catalog Number ▲
Approximate Weight kg (lb)
Conduit Size (Inches)
Mounting Hardware Set Catalog Number
480
0 5 NA AE0BA4W1 36 (80)
1-1/2
AMH7
1 10 NA AE1BA4W1 36 (80)
2 25 NA AE2BA4W1 39 (85)
3 50 NA AE3BA4W1 64 (140) 2
4 100 NA AE4BA4W1 64 (140) 2-1/2
5 200 NA AE5BA4W1 227 (500) 4 AMH8
600
0 5 NA AE0BA6W1 57 (125)
1-1/2
AMH7
1 10 NA AE1BA6W1 57 (125)
2 25 NA AE2BA6W1 59 (130)
3 50 NA AE3BA6W1 88 (195) 2
4 100 NA AE4BA6W1 88 (195) 2-1/2
5 200 NA AE5BA6W1 227 (500) 4 AMH8
Wiring Diagrams
2-WIRE CONTROL ( OFF - ON SEL SW)
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
CONTROL OPTIONS
1
1
1STOP
M
SPACE HEATER
SPACE HEATER
(FOR SEPERATE 208V AND OVER ADD FUSE )
120V SEPARATE CONTROL
FULL VOLTAGE CONTROL
F
1
2
3
2
3
START
2
M
3
( SEE LEFT FOR CONTROL OPTIONS )
2
M
3
TRANSFORMER CONTROL
( SEE LEFT FOR CONTROL OPTIONS )STOPG
OL'SM X2
1
L1
F
H1H3H4 H2
CPT
F
2
1
3
X2
STOPG
RUNR
OL'SX2
L2
F( SEE TAP CHART ON TRANSFORMER )
X1
OFFHAND AUTO
ONOFF
STARTER
THHN/THWN
TYPE
XHHW-2XHHW-2
XHHW-2
L1, L2, L3
WIRE #
L1, L2, L3
L1, L2, L3
L1, L2, L3L1, L2, L3
POWER WIRE
0 #8#8
#1#6
43
3/0
12
SIZEWIRE
SIZE
BLACKBLACK
BLACKBLACKBLACK
COLOR
THHN/THWNXF
WIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
REMOTE
M
RUNRF
NON-COMBINATION STARTER - Size 0 thru 4
L1 L2
L1
L3
L2
M
M
M
OL
OL
OLMOTOR
T1
T3
T2
F F
1 2 3
OL'SX2
STOPG
SPACE HEATER
M
CR
L1 L2
321STOP
M
START
1 3
2
( SEE LEFT FOR CONTROL OPTIONS )
CPT
FX1 X2
H4 H2 H3 H1
CONTROL OPTIONS
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
FF
FOR 120V STARTER COIL
NON-COMBINATION STARTER - Size 5
( SEE LEFT FOR CONTROL OPTIONS )1 2 3 X2
FULL VOLTAGE CONTROLFOR 480V STARTER COILFULL VOLTAGE CONTROL
F
120V SEPARATE CONTROL
(FOR 240V AND OVER ADD FUSE)
L1 L2
REMOTE
OFFHAND AUTO
M
RUNR
OL'S
STOPG
SPACE HEATER
CRM
CR
RUNR
STARTER TYPE
XHHW-2BLACK5 (2) 3/0 L1, L2, L3
WIRE #
POWER WIRE
SIZEWIRE
SIZE COLOR XFWIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
120V
H2
F
H4
CPT
120V X2
H3 H1
F
F
M
L3
L1 L2
M
L1
L2M
MCT
OL
T3
T1
T2MOTOR
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see AEB Series Motor Starters Modifications.
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC EXPLOSIONPROOF MOTOR STARTERS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
287
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Dimensions in Millimeters (Inches) — Starter Only
Enclosure Layout for Size 0, 1 and 2 — Starter Only
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 3 — Starter Only
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
L C
C L
RESET
2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
60 mm(2.38”)
2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
90 mm(3.13”)
90 mm(3.13”)
90 mm(3.13”)
311 mm (12.25”)Mounting
494 mm(19.44)
178 mm(7.00”)
235 mm(9.25”)
Mounting
Left View Front View
246 mm(9.69”)
289 mm(11.38”) 19 mm
(0.75”)359 mm (14.125)
702 mm(27.62”)
Left Side View Front View Top View Bottom View
CONT
ROLS
: NEC
/CEC
EXP
LOSI
ONPR
OOF
MOTO
R ST
ARTE
RS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
288
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Dimensions in Millimeters (Inches) — Starter Only
Enclosure Layout for Size 4 — Starter Only
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56) RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
RESET
L C
C L
2-1/2” NPT
Bottom View
1/2” NPTfor Drain
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
607 mm(23.88)
95 mm(3.75”)
95 mm(3.75”)
95 mm(3.75”)
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
489 mm(19.25”)
Mounting
Left View Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
310 mm (12.19)268 mm (10.56)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 5 — Starter Only C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
C L
L C
RESET
Non-Combination Starter Size 5
Enclosure Layout
243 mm (9.56”)Cover Open 90º
Left View Front View
Top View
Bottom View
1” NPT4” NPT
546 mm (21.50”)Cover Open 130º
114 mm(4.50”)
114 mm(4.50”)
114 mm(4.50”)
4” NPT
1/2” NPTfor Breather
89 mm(3.50”)
89 mm(3.50”)
1/2” NPTfor Drain
864 mm(34.00”)
572 mm (22.50”)Mounting
19 mm(0.75”)
664 mm (26.13)
1168 mm(46.00”)
699 mm(27.50”)
Mounting
379 mm(14.94”)
421 mm(16.56”)
269 mm(10.60”)
Left Side View Front View Top View Bottom View
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC EXPLOSIONPROOF MOTOR STARTERS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
289
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Combination Full Voltage Motor Starters With Motor Circuit Protector (MCP) — Nonreversing — 3-Phase, 60 Hertz, 120 V Coil
Line Voltage
NEMA Size
Maximum Horsepower
Amp Trip Catalog Number ▲
Approximate Weightkg (lb)
Conduit Size (Inches)
Mounting Hardware Set Catalog Number
480
0
1 3 AE0BB4W1C1 57 (125)
1-1/2
AMH7
3 7 AE0BB4W1C2 57 (125)
5 15 AE0BB4W1C3 57 (125)
1 7 15 AE1BB4W1C3 57 (125)
10 30 AE1BB4W1C4 59 (130)
212 30 AE2BB4W1C4 59 (130)
25 50 AE2BB4W1C5 59 (130)
330 50 AE3BB4W1C5 88 (195)
2-1/250 100 AE3BB4W1C7 88 (195)
4 100 150 AE4BB4W1C8 88 (195)
5 200 400 AE5BB4W1C0 227 (500) 4 AMH8
600
0
1 3 AE0BB6W1C1 57 (125)
1-1/2
AMH7
3 7 AE0BB6W1C2 57 (125)
5 15 AE0BB6W1C3 57 (125)
17 15 AE1BB6W1C3 57 (125)
10 30 AE1BB6W1C4 57 (125)
220 30 AE2BB6W1C4 59 (130)
25 50 AE2BB6W1C5 59 (130)
340 50 AE3BB6W1C5 88 (195)
2-1/250 100 AE3BB6W1C7 88 (195)
460 100 AE4BB6W1C7 88 (195)
100 150 AE4BB6W1C8 88 (195)
5 200 400 AE5BB6W1C0 227 (500) 4 AMH8
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see AEB Series Motor Starters Modifications.
CONT
ROLS
: NEC
/CEC
EXP
LOSI
ONPR
OOF
MOTO
R ST
ARTE
RS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
290
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Combination Full Voltage Motor Starters With Motor Circuit Protector (MCP) — Nonreversing— 3-Phase, 60 Hertz, 120 V Coil
Wiring Diagram
2-WIRE CONTROL ( OFF - ON SEL SW)
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
CONTROL OPTIONS
1
1
1STOP
M
SPACE HEATER
SPACE HEATER
(FOR SEPERATE 208V AND OVER ADD FUSE )
120V SEPARATE CONTROL
FULL VOLTAGE CONTROL
F
1
2
3
2
3
START
2
M
3
( SEE LEFT FOR CONTROL OPTIONS )
2
M
3
TRANSFORMER CONTROL
( SEE LEFT FOR CONTROL OPTIONS )STOPG
OL'SM X2
1
L1
F
H1H3H4 H2
CPT
F
2
1
3
X2
STOPG
RUNR
OL'SX2
L2
F( SEE TAP CHART ON TRANSFORMER )
X1
OFFHAND AUTO
ONOFF
STARTER
THHN/THWN
TYPE
XHHW-2XHHW-2
XHHW-2
L1, L2, L3
WIRE #
L1, L2, L3
L1, L2, L3
L1, L2, L3L1, L2, L3
POWER WIRE
0 #8#8
#1#6
43
3/0
12
SIZEWIRE
SIZE
BLACKBLACK
BLACKBLACKBLACK
COLOR
THHN/THWNXF
WIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
REMOTE
M
RUNRF
L1
L2
L3
COMBINATION STARTER - Size 1 thru 4
L1 L2
CB
M
M
M
MOTOR
OL
OL
OL
T1
T3
T2
F F
1 2 3
OL'SX2
STOPG
SPACE HEATER
M
CR
L1 L2
321STOP
M
START
1 3
2
( SEE LEFT FOR CONTROL OPTIONS )
CPT
FX1 X2
H4 H2 H3 H1
CONTROL OPTIONS
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
FF
L3
L1
L2M
L2L1
CB CT
M
M
FOR 120V STARTER COIL
COMBINATION STARTER - Size 5
( SEE LEFT FOR CONTROL OPTIONS )1 2 3 X2
FULL VOLTAGE CONTROLFOR 480V STARTER COILFULL VOLTAGE CONTROL
F
120V SEPARATE CONTROL
(FOR 240V AND OVER ADD FUSE)
L1 L2
REMOTE
OFFHAND AUTO
M
RUNR
OL'S
STOPG
SPACE HEATER
CRM
CR
RUNR
STARTER TYPE
XHHW-2BLACK5 (2) 3/0 L1, L2, L3
WIRE #
POWER WIRE
SIZEWIRE
SIZE COLOR XFWIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
120V
OL
T3
T1
T2MOTOR
H2
F
H4
CPT
120V X2
H3 H1
F
F
M
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC EXPLOSIONPROOF MOTOR STARTERS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
291
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Dimensions in Millimeters (Inches) — CombinationEnclosure Layout for Size 0, 1 and 2 — Combination
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 3 and 4 — Combination
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 5 — CombinationC L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
Left Side View Front View Top View Bottom View
CONT
ROLS
: NEC
/CEC
EXP
LOSI
ONPR
OOF
MOTO
R ST
ARTE
RS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
292
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Combination Full Voltage Motor Starters with Thermal Magnetic Circuit Breaker – Nonreversing — 3-Phase, 60 Hertz, 120 V Coil
Line Voltage
NEMA Size
Maximum Horsepower
Amp Trip Catalog Number ▲
Approximate Weightkg (lb)
Conduit Size (Inches)
Mounting Hardware Set Catalog Number
480
03 15 AE0BB4W1CA 57 (125)
1-1/2
AMH7
5 20 AE0BB4W1CB 57 (125)
17-1/2 30 AE1BB4W1CD 57 (125)
10 35 AE1BB4W1CE 57 (125)
220 50 AE2BB4W1CG 59 (130)
25 70 AE2BB4W1CJ 59 (130)
350 100 AE3BB4W1CN 88 (195)
2-1/260 125 AE3BB4W1CP 88 (195)
475 150 AE4BB4W1CQ 88 (195)
100 200 AE4BB4W1CS 88 (195)
5
125 250 AE5BB4W1CU 227 (500)
4 AMH8150 300 AE5BB4W1CV 227 (500)
200 400 AE5BB4W1CX 227 (500)
600
0 5 15 AE0BB6W1CA 57 (125)
1-1/2
AMH7
17-1/2 20 AE1BB6W1CB 57 (125)
10 30 AE1BB6W1CD 57 (125)
215 40 AE2BB6W1CF 59 (130)
25 50 AE2BB6W1CG 59 (130)
330 70 AE3BB6W1CJ 88 (195)
2-1/250 100 AE3BB6W1CN 88 (195)
475 125 AE4BB6W1CP 88 (195)
100 150 AE4BB6W1CQ 88 (195)
5150 250 AE5BB6W1CU 227 (500)
4 AMH8200 300 AE5BB6W1CV 227 (500)
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see AEB Series Motor Starters Modifications.
CONTROLS: NEC/CEC EXPLOSIONPROOF MOTOR STARTERS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
293
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Combination Full Voltage Motor Starters with Thermal Magnetic Circuit Breaker – Nonreversing — 3-Phase, 60 Hertz, 120 V Coil
Wiring Diagram
2-WIRE CONTROL ( OFF - ON SEL SW)
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
CONTROL OPTIONS
1
1
1STOP
M
SPACE HEATER
SPACE HEATER
(FOR SEPERATE 208V AND OVER ADD FUSE )
120V SEPARATE CONTROL
FULL VOLTAGE CONTROL
F
1
2
3
2
3
START
2
M
3
( SEE LEFT FOR CONTROL OPTIONS )
2
M
3
TRANSFORMER CONTROL
( SEE LEFT FOR CONTROL OPTIONS )STOPG
OL'SM X2
1
L1
F
H1H3H4 H2
CPT
F
2
1
3
X2
STOPG
RUNR
OL'SX2
L2
F( SEE TAP CHART ON TRANSFORMER )
X1
OFFHAND AUTO
ONOFF
STARTER
THHN/THWN
TYPE
XHHW-2XHHW-2
XHHW-2
L1, L2, L3
WIRE #
L1, L2, L3
L1, L2, L3
L1, L2, L3L1, L2, L3
POWER WIRE
0 #8#8
#1#6
43
3/0
12
SIZEWIRE
SIZE
BLACKBLACK
BLACKBLACKBLACK
COLOR
THHN/THWNXF
WIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
REMOTE
M
RUNRF
L1
L2
L3
COMBINATION STARTER - Size 1 thru 4
L1 L2
CB
M
M
M
MOTOR
OL
OL
OL
T1
T3
T2
F F
1 2 3
OL'SX2
STOPG
SPACE HEATER
M
CR
L1 L2
321STOP
M
START
1 3
2
( SEE LEFT FOR CONTROL OPTIONS )
CPT
FX1 X2
H4 H2 H3 H1
CONTROL OPTIONS
3-WIRE CONTROL (START & STOP )
2-WIRE CONTROL ( H-O-A SEL SW)
FF
L3
L1
L2M
L2L1
CB CT
M
M
FOR 120V STARTER COIL
COMBINATION STARTER - Size 5
( SEE LEFT FOR CONTROL OPTIONS )1 2 3 X2
FULL VOLTAGE CONTROLFOR 480V STARTER COILFULL VOLTAGE CONTROL
F
120V SEPARATE CONTROL
(FOR 240V AND OVER ADD FUSE)
L1 L2
REMOTE
OFFHAND AUTO
M
RUNR
OL'S
STOPG
SPACE HEATER
CRM
CR
RUNR
STARTER TYPE
XHHW-2BLACK5 (2) 3/0 L1, L2, L3
WIRE #
POWER WIRE
SIZEWIRE
SIZE COLOR XFWIRE NUMBER
CONTROL WIRE
GNDCONTROL
X2
WIRE SIZE
GREENWHITE
RED
COLOR
RED#14
#14#14
TYPE
#14THHN/THWNTHHN/THWNTHHN/THWNTHHN/THWN
TYPEWIRE # COLORWIRE
#12SIZE
BLACKL1, L2
XFMR POWER WIRE
THHN/THWN
120V
OL
T3
T1
T2MOTOR
H2
F
H4
CPT
120V X2
H3 H1
F
F
M
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
EXP
LOSI
ONPR
OOF
MOTO
R ST
ARTE
RS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
294
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
Dimensions in Millimeters (Inches) — CombinationEnclosure Layout for Size 0, 1 and 2 — Combination
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 3 and 4 — Combination
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
RESET
L C
C L
O F F N O
2-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
95 mm(3.75”)
Bottom View
1/2” NPTfor Drain95 mm
(3.75”)95 mm(3.75”)
607 mm(23.88”)
1” NPT
383 mm (15.06”)Cover Open 130º
195 mm (7.69”)Cover Open 90º
413 mm (16.25”)Mounting
2-1/2” NPT
Front View
19 mm(0.75”) 461 mm (18.13)
803 mm(31.63”)
195 mm(7.69”)
327 mm (12.88”)
489 mm(19.25”)
Mounting
Left View
268 mm(10.56”)
310 mm(12.19”)
Left Side View Front View Top View Bottom View
Enclosure Layout for Size 5 — CombinationC L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
C L
L C
RESET
O F F N O
Front View
19 mm(0.75”) 664 mm (26.13)
1168 mm(46.00”)
269 mm(10.60”)
435 mm (17.12”)
699 mm(27.50”)
Mounting
Left View
379 mm (14.94”)
421 mm (16.56”)
4” NPT
Top View
1/2” NPTfor Breather
90 mm(3.50”)
114 mm(4.50”)
114 mm(4.50”)
572 mm (22.50”)Mounting
114 mm(4.50”)
864 mm(34.00”)
4” NPT1” NPT
90 mm(3.50”)
Bottom View
546 mm (21.50”)Cover Open 130º
259 mm (10.19”)Cover Open 90º
1/2” NPTfor Drain
Left Side View Front View Top View Bottom View
CONTROLS: NEC/CEC EXPLOSIONPROOF MOTOR STARTERS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
295
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Lighting Contactor — 3-Pole — 60 Hertz, 120 V Coil
Line Voltage
Emclosure Size
Contactor Amps
Number of Poles Catalog Number ▲
Approximate Weightkg (lb)
Conduit Size (Inches)
Mounting Hardware Set
Catalog Number
120 1 30
3 AE1BM1S13
57 (125) 1-1/2 AMH76 AE1BM1S16
9 AE1BM1S19
12 AE1BM1S112
Wiring Diagram
(SEE TAP CHART ON XFMR) F
G OFF
R ON
ON R
OFF G
F F
L1 L2
120V SEPARATE CONTROL
(FOR 208V AND OVER ADD FUSE )
CPT
F 1 X2
H4 H2 H3 H1
L1 L2
L2
L3
L1
C
C
C
NON-COMBINATION CONTACTOR
FULL VOLTAGE CONTROL
WIRING SHOWN FOR 3 POLES ONLY
F
3
2
HAND
1
AUTO OFF
X2
HAND
1
2
AUTO OFF
3 X2
TRANSFORMER CONTROL
ON OFF
ON
3 2
OFF 1
3 1
CONTROL OPTIONS
2-POSITION SELECTOR SWITCH CONTROL
PUSHBUTTON CONTROL
X1
M
C
SPACE HEATER
C
PC
PC
SPACE HEATER
PC
C
PC
C
Dimensions in Millimeters (Inches) — Lighting Contactor C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
C L
10 x 12
RESET
L C
178 mm(7.00”)
225 mm(8.875”)
Mounting
Left View Front View
241 mm(9.50”)
281 mm(11.062”)
19 mm(0.75”) 359 mm (14.125)
422 mm(16.625”)
1-1/2” NPT
Top View
Bottom View
1/2” NPTfor Breather
1/2” NPTfor Drain
60 mm(2.38”)
79 mm(3.125”)
79 mm(3.125”)
79 mm(3.125”)
494 mm(19.44”)
60 mm(2.38”)
1” NPT1-1/2” NPT
310 mm (12.19”)Cover Open 130º
167 mm (6.56”)Cover Open 90º
311 mm (12.25”)Mounting
Left Side View Front View Top View Bottom View
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see AEB Series Motor Starters Modifications.
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
EXP
LOSI
ONPR
OOF
MOTO
R ST
ARTE
RS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
296
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Combination Lighting Contactor — 3-Pole — 60 Hertz, 120 V Coil
Line Voltage
Emclosure Size
Contactor Amps
Contactor Amps
Number of Poles Catalog Number ▲
Approximate Weightkg (lb)
Conduit Size (Inches)
Mounting Hard-ware Set Catalog
Number
120 1 30 40
3 AE1BN1S1F3
57 (125) 1-1/2 AMH76 AE1BN1S1F6
9 AE1BN1S1F9
12 AE1BN1S1F12
Wiring Diagram
(SEE TAP CHART ON XFMR) F
G OFF
R ON
ON R
OFF G
F F
L1 L2
120V SEPARATE CONTROL
(FOR 208V AND OVER ADD FUSE )
CPT
F 1 X2
H4 H2 H3 H1
FULL VOLTAGE CONTROL
WIRING SHOWN FOR 3 POLES ONLY
F
3
2
HAND
1
AUTO OFF
X2
HAND
1
2
AUTO OFF
3 X2
TRANSFORMER CONTROL
ON OFF
ON
3 2
OFF 1
3 1
CONTROL OPTIONS
2-POSITION SELECTOR SWITCH CONTROL
PUSHBUTTON CONTROL
X1
M
C
SPACE HEATER
C
PC
PC
SPACE HEATER
PC
C
PC
C
L3
L2
L1
CB
C
C
C
L2L1
COMBINATION LTG. CONTACTOR
Dimensions in Millimeters (Inches) — Combination Lighting ContactorL C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
L C
C L
O F F N O
RESET
1-1/2” NPT
Top View
1/2” NPTfor Breather
60 mm(2.38”)
80 mm(3.13”)
Bottom View
1/2” NPTfor Drain
80 mm(3.13”)
80 mm(3.13”)
494 mm(19.44”)
60 mm(2.38”)
1-1/2” NPT
1” NPT
310 mm (12.19”)Cover Open 130º
183 mm (7.19”)Cover Open 90º
311 mm (12.25”)Mounting
Front View
19 mm(0.75”) 359 mm (14.13)
702 mm(27.63”)
178 mm(7.00”)
305 mm(12.00”)
489 mm(19.25”)
Mounting
Left View
246 mm(9.69”) 289 mm
(11.38”)
Left Side View Front View Top View Bottom View
▲ To complete the catalog number please add the appropriate suffix for other options/features. Suffixes, see AEB Series Motor Starters Modifications.
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONTROLS: NEC/CEC EXPLOSIONPROOF MOTOR STARTERS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
297
NEC/CEC: Class I, Division 1 and 2, Groups B, C, D Class I, Zone 1 and 2, Groups IIB + H2 Class II, Division 1 and 2, Groups E, F, G Class III
NEC/CEC: NEMA 4, 4X, 7BCD, 9EFG CSA Type 4, 4X
Modifications
Description
Suffix Factory Installed
Catalog Number
Field Installed
Operators
Start/Stop dual push button S3X AEPDGRE
Stop push button S2X AEPRC
Start push button S1X AEPGA
Stop, lighted PB, red 120 Vac LP5X AEPTRE
Start, lighted PB, green 120 Vac LP4X AEPTGE
3 position selector switch specify legend A3X AESS31MN
2 position selector switch specify legend A2X AESS22ML
Red pilot light, 120 Vac L5 AEPL1R
Green pilot light, 120 Vac L4 AEPL1G
Red pilot light, 240 Vac L52 AEPL2R
Green pilot light, 240 Vac L42 AEPL2G
Red pilot light, 480 Vac L54 AEPL4R
Green pilot light, 480 Vac L44 AEPL4G
NEMA 4X Breather/Drain Fittings
Drain fitting DN DRNB4X
Breather fitting (Drilled and tapped installation included.)
BR BRTB4X
Control Power Options
Fused CPT, 50 Va T1 AFCPT050
Fused CPT, 100 Va T2 AFCPT100
Fused CPT, 200 Va T3 AFCPT200
Fused CPT, 250 Va T4 AFCPT250
Fused CPT, 50 Va w/interposing relay T5 AFCPT050R
Fused CPT, 150 Va T6 AFCPT150
Fused CPT, 300 Va T7 AFCPT300
Fused CPT, 500 Va T8 AFCPT500
Fused CPT, 750 Va T9 AFCPT750
Separate control fused circuit S-120V n/a
Specify starter coil voltage S-240V n/a
S-480V n/a
Description
Suffix Factory Installed
Catalog Number
Field Installed
Nameplates
Engraved nameplate — black letters on white surface, 50.8 x 101.6 mm (2” x 4”), 3.18 mm (0.125” ) letters, 3 lines max. specify legend
NP n/a
Space Heater
40 Watt enclosurespace heaters
120 Vac O-120V AFA4327X11
240 Vac O-240V AFA4327X12
480 Vac O-480V AFA4327X13
Control Terminal Blocks (Above 12 points contact your local representative)
20 Amp, 600 Vac 8 point 8K n/a
NEMA 1B w/wire markers 12 point 12K n/a
Cutler-Hammer ✢ Starter Auxiliary Contacts
Size 0-4 1NO/1NC X11C AJ-11
2NO/2NC X22C AJ-11 (2 ea.)
Size 5 1NO/1NC X511C A3463D94G18
2NO/2NC X522C A3463D94G18 (2 ea.)
Square D Starter Auxiliary Contacts
Size 0-5 1NO/1NC X11S A999SX8
2NO/2NC X22S A999SX8 (2 ea.)
Number of Poles on Lighting Contactors
30 Amp, 120 Vac 3 Poles 3
30 Amp, 120 Vac 6 Poles 6
30 Amp, 120 Vac 9 Poles 9
30 Amp, 120 Vac 12 Poles 12
NOTE: CPT includes primary and secondary fuses. Add —L to part no. for Size 5 starters. Size 1 and 2 150 Vac Max. Size 3 and 4 300 Vac Max. Contact your local representative for other voltages. 8 Aux. Contacts Max. includes one seal-in and seven added. 4 Aux. Contacts Max. includes one seal-in and three added. Size 0-1 includes one seal-in and four added. Size 2-5 includes one seal-in and three added.✢ Cutler-Hammer is a registered trademark of Eaton Corporation. Square D is a registered trademark of Schneider Electric.
AEB Series Bolted Motor Starters and ContactorsExplosionproof, Dust-Ignitionproof, WatertightFull Voltage. Combination and Non-Combination.
CONT
ROLS
: NEC
/CEC
EXP
LOSI
ONPR
OOF
MOTO
R ST
ARTE
RS
Visit our website at www.emerson.com or contact us at (800) 621-1506. © June 2017
298
