Triumph Spitfire mkIV 1973 and Spitfire 1500 Parts Catalogue

I(

BRITISH

Triumph Spitfire MklV (1973)

~ and Spitfire 1500 Part No. RTC 9008

Parts Catalogue June 1973LEYLAND

BRITISH LEYLAND UK LIMITEDParts and AccessoriesJaguar and Rover TriumphTriumph MotorsFletchamstead HighwayCoventry CV4 90B

Telephone: 020375511

Telex: 31567

Telegrams: Stanpart Coventry

ERRATUMRTC 9008 should read RTC 9008A.

"I

IIIIi'Ii

I

I:I

Whilst every effort is made to ensure the accuracy of the particulars contained in this Manual, the ManufacturingCompanies will not, in any circumstances, be held liable for any inaccuracies or the consequences thereof.

© Parts and Accessories Jaguar and Rover Triumph 1973

All rights reserved. No part of this publication may be reproduced, stored in a retrieval system or transmittedany form, electronic mechanical, photocopying, recording or other means without prior written permissi r

Parts and Accessories Jaguar and Rover Triumph.

INTRODUCTION

This publication is completely pictorial, that is, a pictorial group index, page index and part numbered illustrationswith no description. This gives a quicker look-up time and obviates the need for translation. The part numberquoted on the illustrations is common to all models covered by the publication, unless otherwise stated against theheading, the part number or in the section at the bottom of the illustration.

The quantity for any part number is always one off unless a higher quantity is shown in brackets against the partnumber.

Users should make themselves familiar with the various symbols and abbreviations which are used in thepresentation of the publication to denote, amongst other things, Right hand Steering, Left hand Steering,assemblies and components of kits.

The official description of the part, where this information is needed, is shown in the numerical index at the end ofthe publication. The index also gives the page number on which each part appears.

INTRODUKTION

Denne publikation fremtraeder kun med illustrationer, dvs. et gruppe·indeks,et side·indeks og illustreredereservedelsnumre uden beskr'ivelse. Dermed er bogen hurtigere at bruge, og man undgar at skulle oversaette. Detreservedelsnummer, der er anfl'lrt ved illustrationerne, er faelles for aile de modeller, der omfattes af publikatlonen,med mindre andet er anfrlJrt i overskriften, ved reservedelsnummeret eller i afsnittet forneden ~ illustrationen.

For enhver reservedel er der altid tale om et styk, med mindre et andet kvantum er anf0rt i parantes ud forreservedelsnummeret.

Man bl'lr saette sig Inde I de forskellige symboler og forkortelser, der bruges i denne publikation for f.eks. at angivehl'ljrestyring, venstrestyring, aggregater og dele i saet.

Den officielle beskrivelse af en reservedel er, hvor denne oplysning er ~kraevet, anflllrt i det numeriske indeks sidsti publikationen. Dette indeks viser ogsa, pa hvilken side den enkelte reservedel findes.

INLEIDING

Deze uitgave is volledig geillustreerd en bevat een inhoudsopgave van de onderdelengroepen en bladzijden, evenalseen opgave van aparte onderdelen in de vorm van genummerde illustraties zonder nadere toelichting. Op deze wijzewordt het opzoeken vergemakkelijkt en zijn vertalingen overbodig. De onderdelennummers in de illustraties zijnvan toe passing op aile modellen die in de uitgave zijn genoemd, tenzij het tegendeel is vermeld bovenaan debladzijde, bij het onderdeelnummer of onder de betreffende illustratie.

Het aantal onderdelen bedraagt steeds 1 stuks, tenzij een groter aantal tussen haakjes bij het onderdeelnummer isvermeld.

Gebruikers worden verzocht zich vertrouwd te maken met de verschillende symbolen en afkortingen die in dezeuitgave zijn vermeld en die o.a. dienen voor het aanduiden van wagens met rechts of links stuur, samengesteldeonderdelen, aparte onderdelen of sets.

De officiale beschrijving van de onderdelen is, indien belangrijk, vermeld in de numerieke inhoudsopgave aan heteind van het boek. In de inhoudsopgave zijn tevens de nummers van de bladzijden vermeld waarop de onderdelenzijn afgebeeld.

I.ITHOGRAPHED IN ENGLAND BY THE NUfHELD PRESS LIMITED, COWLEY, OXFORD. 27lJ (87024) 6!74-3,OOO

INTRODUZIONE

La presente pubblicazione e completamente illustrata, costituita cioe da un indice dei gruppi illustrato, dall'indicedelle pagine e dalle illustrazioni dei pezzi senza denominazlone 0 descrizione. Questa soluzione permette una pi"raplda consultazlone ed elimina la necessita della traduzione. II numero dei particolari indicati nelle illustrazionisono in comune per tutti i modelli cui la pubblicazione si riferisce, eccetto quando vi sono precise indicazioni incontrario nelle intestazioni, vicino ai numeri di pezzo 0 nella sezione stessa in fondo all'i1lustrazione.

La quantitil di ogni particolare e sempre di un pezzo, tral;lne quando maggiorl quantitativi sono indicati traparentesi a fianco del numero di pezzo.

Coloro che dovranno usare la pubblicazione faranno bene a studiare I varl simbol i ed abbrevlazioni ·usate nellapresentazione, che denotano, tra I'altra, 10 sterzo a destra, 10 sterzo a sinistra, i complessivi ed i particolari checompongono i corredi completi.

La denominazione ufficiale del pezzo, ove tale informazione sia necessaria, compare nell'indice numerico alia finedella pubblicazione. L'indice mostra anche il numero di pagina per ogni particolare Ivi rappresentato.

INTRODUCAO

A presente publicaeao e completamente ilustrada, quer dizer, ha indice em forma de grupo i1ustrado, indice depaginas e i1ustraeoes com peea nos. sem descrieao. Isto proporciona tempo lOa is rapido para buscar e evita anecessidade de traduzir. 0 peea no. citado nas i1ustraeoes aplica-se para todos modelos nesta publicaeao, salvoindicaeao contraria contra 0 titulo, 0 peca numero ou na seeao no fundo da ilustraeao.

A quantidade para qualquer peea no. e sempre de uma peea, salvo indica~ao contraria, quer dizer, de quantldadesuperior, indicada entre parenteses contra 0 peea numero.

Os Senhores usuarios devem familiar-se com os diversos simbolos e abreviaeoes que empregam-se na presentaeao dapublicaeao para Indicar, entre outras coisas, volante iI direita, volante a esquerda, componentes de conjuntos deinstrumentos.

A descri~ao oficlal da peea, onde precisa-se desta informaeao, esta indicada no indice numerico situado no fim dapublicaeao. 0 Indlce tambem praporciona 0 numero de pagina na qual cada peea acha-se.

INTRODUCCION

Esta publicaci6n es completamente pict6rica, es decir, uh indice de grupo plct6rico, indice de pagrnas ei1ustraciones numeradas de piezas sin descripcl6n alguna. Con esto se tarda men os en buscar las piezas y se evita lanecesidad de traducci6n. EI numero de pieza indicado en las ilustraciones es comun a todos los modelos incluidosen la publicaci6n, a menos que se diga 10 contrario en el encabezamiento, en el numero de pieza 0 en la secci6n enla parte inferior de la iiustraci6n.

La cantidad de cualquier numero de pieza se refiere siempre a una unldad a menos que se muestre mayor cimtidadentre parentesis al lado del numero de pieza.

Los usuarios deberan familiarizarse con los dlferentes simbolos y abreviaturas empleadas en la publlcaci6n paraindicar, entre otras cosas, Direcci6n a la Derecha, Direcci6n a la Izquierda, conjuntos y componentes de juegos.

La descripci6n oficial de la pieza, en los casos en que se necesite esta informaci6n, aparece en el indice numerico alfinal de la publicaci6n. Tambien se da en el indice el numera de la pagina en la que aparece cada pieza.

ESITTELY

Tama on pelkastaan kuvajulkaisu, jossa on kuvitettu ryhmahakemisto, sisallysluettelo ja ilman nimikkeita laadittukuvallinen varaosanumeroiden luettelo. Kirjan kaytto nopeutuu, koska kaantaminen ei ole tarpeen. Kuvissa esitetytvaraosanumemt sopivat kaikkiin kirjan estittiimiin malleihin ellei otsikossa varaosanumeron yhteydessa tai kuvanalia ole toisin mainittu.

Jokaista osaa tarvitaan yksi kappale, ellei suurempaa maaraa ole mainittu sulkumerkeissa varaosanumeronyhteydessa.

Kiiyttajien on tutustuttava julkaisussa kaytettyihin erilaisiin merkkeihin ja Iyhennyksiin huomioidakseen mm.oikean tai vasemmanpuoleisen ohjauksen, osa-asetelmat ja korjaussarjat.

Niista osista, joiden sanallinen nimike on tarpeen, on kirjan lopussa numeroitu luettelo, jossa on myos mainittu,milia kirjan sivulla k.o. osa on kuvattu.

INTRODUCTION

Cette publication est entierement illustree, c'est-a-dire qu'elle comprend un index des figures, un index des pages etdes figures avec les numeros de piece mais sans aucune designation. Cela permet une recherche plus rapide etsupprime la mkessite de la traduction. Le numero de piece indique pour chaque figure est commun a tous lesmodeles couverts par la publication sauf s'il en est autrement specifie dans I'en-tete, avec Ie numero de piece ousous la figure.

Pour chaque numero de piece la quantite est toujours egale a UN sauf si une quantite plus elevee est inscrite entreparenthese a cote du numero de piece.

Les utilisateurs devront se familiariser avec les symboles et les abreviations employes dans la presentation de cettepublication pour indiquer, entre autres, Direction a Droite, Direction a Gauche, Ensembles et Pieces composant unlot.

La designation officielle de la piece, lorsqu'elle est necessaire, figure dans I'index numerique qui se trouve a la fin dela publication. Cet index donne egalement Ie numero de la page dans laquelle chaque piece est representee.

EINFUHRUNG

Diese Veroffentlichung besteht lediglich aus Abbildungen, d.h. einem bildlichen Gruppenindex, Seitenindex undteilebezeichneten Abbildungen ohne Beschreibung. Dies erleichtert das Nachschlagen und erubrigt Ubersetzungen.Die in den Abbildungen aufgefuhrten Teilenummern sind allen in dieser Broschure erwahnten Modellen gleich,au~er wenn in der Uberschrift, neben der Teilenummer oder im Abschnitt unten in der Abbildung andersangegeben.

Bel den Teilenummern handelt es sich jeweils um ein Einzelstuck, au~er wenn in Klammern neben derTeilenummer eine gro~ere Menge verzeichnet ist.

Machen Sie sich bitte mit den verschiedenen Symbolen und Abkurzungen vertraut, die u.a. Rechtslenker,Linkslenker, Gruppen und Satzbestandteile darstellen.

Sofern notwendig. kann die offizielle Beschreibung eines Teiles im Nummernverzeichnis am Ende dieser Broschurenachgeschlagen werden. 1m Index ist ebenfalls die Seitennummer jedes Teiles aufgefUhrt.

INTRODUKTION

Denna publikation ar helt illustrerad, d.v.s. den har i1lustrerat gruppindex, sidoindex och illustrationer fOrseddamed detaljnummer utan beskrivning. Detta gor det lattare att snabbt hitta ratt och gor dessutom oversattningoverflodig. Det detaljnummer som ange. p8 resp. illustration ar lika for alia modeller som tacks av publikationen.savida inget annat anges i rubriken, vid sjalva detaljnumret eller i sektionen under illustrationen.

Antalet detaljer for varje detaljnummer ar alltid en, savida inte en hogre kvantitet anges inom parentes vid detberorda detaljnumret.

Den som anvander katalogen bor gora sig fortrogen med de olika symbolerna och fiirkortningarna som anvands ochsom bl.a. anger hiigerstyrning, vansterstyrning. enheter och komponenter i satser.

Den officiella beskrivningen av detaljen, dar sadan information erfordras. anges i det nummerindex som finns islutet av publikationen. I detta index anges ocksa den sida. pa vilken detaljen finns upptagen.

EXTERIOR PAINT AND TRIM CODE PROCEDUREThe following coding system has been devised to cover the basic colours and their varying shades,

(a) Basic Colours.There are nine Basic Colours, their numbers are:1, Black 4. Yellow 7. Purple2. Red 5. Green 8. Grey3, Brown 6. Blue 9. White

(b) Shades of Colour.To cover Shades of the' above Colours, a second figure commencing at '1' is used as a prefix to the above numbers,range of codes is as follows:-

Basic Colour 1st Shade 2nd Shade 3rd Shade 4th Shade 5th Shade

Black 11 Black

Red 72 Pimento 82 Carmine 92 Magenta

Brown 23 Sienna 33 New ran 63 Chestnut

Yellow 64 Mimosa

Green 65 Emerald

Blue 106 Mallard 126 French 96 SapphireBlue

Purple 27 ShadowBlue

Grey

White 19 White

(cl Dual Colours.

Dual colours are shown as two codes divided by a stroke, the first code being the predominant colours, e,g. 26/11denotes Wedgwood Blue and Black.

(d) Trim Materials.Prefix Letters added to the colour code indicate the main trim material

Leathercloth - No prefix letter, Leather - Prefix letter'H', Cloth - Prefix Jetter 'C',

(e) Recording.The paint, trim colours and materials used are recorded in the spaces provided on the Commission No. Plate.

LAKKEN BUITENWERK EN TRIM KODERINGHet volgende kodeersysteem is opgesteld voor de grondkleuren en hun diverse tinten.

(a) GrondkleurenEr zijn negen Grondkleuren, hun cijferszijn:1. Zwart 4. Geel 7. Violet2. Rood 5. Groen 8. Grijs3. Bruin 6. Blauw 9. Wit

(b) Tinten van de kleur.

am de diverse tinten van de bovenstaande kleuren aan te geven, wordt een tweede cijfer gebruikt beginnende met '1'vDDr de bovengenoemde cijfers, de kodering is als volgt:-

Grondkleur 1e tint 2e tint 3e tint 4e tint 5e tint

Zwart 11 Black

Rood 72 Pimento 82 Carmine 92 Magenta

Bruin 23 Sienna 33 New Tan 63 Chestnut

Geel 64 Mimosa

Groen 65 Emerald

Blauw 106 Mallard126 French 96 Sapphire

Blue

Violet27 Shadow

Blue

Grijs

Wit 19 White

(c) Twee kleuren.Twee kleuren worden aangegeven als twee kodes, gescheiden door een streep, de eerste kode is de hoofdkleur, b.v.26/11 duidt aan Wedgwood blauw en zwart.

(d) Trim materialen.Letters v66r de kleurenkode geven het hoofdtrimmateriaal aan.

Leerdoek - Geen v66rletter; Leer - Zet de letter 'H' v66r de kode. Weefsel - zet de letter 'C' v66r de kode.

(e) Registratie.De lak, trimkleuren en gebruikte materialen worden aangegeven op de betreffende plaatsen op deordernummerplaat.

UlKOMAALIN JA VERHOllUN KOODITUSSeuraava koodijiirjestelmii on kehitetty osoittamaan perusviirit ja niiden avyt.

(a) Perusviirit.Tarjolla on yhdeksan perusvaria; niiden numeral oval:1. Musta 4. Keltainen 7. Purppura2. Punai nen 5. Vihrea 8. Harmaa3. Ruskea 6. Sininen 9. Valkoinen

(bl Viirisiivyt.Yllamainittujen varien savyjen luokittelemiseksi kayletaan loista numeroa yhdesta alkaen em. numeroiden edessa janaon saadaan seuraaval koodil:

Perusviir; 1. siivy 2. siivy 3, siivy 4. siivy 5. siivy

Musta 11 Black

Punainen 72 Pimento B2 Carmine 92 Magenta

Ruskea 23 Sienna 33 New Tan 63 Chestnut

Keltainen 64 Mimosa

Vihreii 65 Emerald

Sininen 106 Mallard 126 French96 SapphireBlue

Purppura 27 ShadowBlue

Harmaa

Valkoinen 19 White

(el Kaksoisvarit.Kaksoisvarit osoitetaan kahdella koodilla, joita poikkiviiva eraittaa. Ensimmainen koodi on vallitseva vari, esim.26/11 tarkoimia Wedgwood sininen ja musta".

(d) Verhoiluaineet.Kirjain varikoodin edessii osoittaa paaverhoiluaineen.

Keinonahka-Ei etukirjainta; nahka- etukirjain "H", Kangas-etukirjain "C".

(el Rekisterointi.Maali, verhoilun viirit ja materiaalit on rekisteroity agentin numerolaattaan varatussa tilassa.

\

I '

SYMBOLES UTILISES POUR LES COLORIS EXTERIEURS ET LA GARNITURE INTERIEURELes symboles suivants servent pour les coloris fondamentaux et les differentes nuances de ces colom:

(a) Coloris fondamentaux.Neuf coloris fondamentaux sont utilises, les numeros sU'vants leur ont He attribues:1, Noir 4. Jaune 7. Violet2. Rouge 5. Vert 8. Gris3, Marron 6. Bleu 9. Blanc

(b) Nuances.Pour obtenir un code englobant toutes les differentes nuances des coloris ci-dessus,un prMixe numeral commencantil '1' leur a ete anribue. Le code complet est donne ci-dessous;-

Colorislere nuance 2eme nuance 3eme nuance 4eme nuance 5eme nuance

fontlamental

Noir 11 Black

Rouge 72 Pimento 82 Carmine 92 Magenta

Marron 23 Sienna 33 New Tan 63 Chestnut

Jaune 64 Mimosa

Vert 65 Emerald

Bleu 106 Mallard 126 French 96 SapphireBlue

Violet27 Shadow

Blue

Gris

Blanc 19 White

(c) Fini en deux color isQuand Ie fini est en deux coloris, Ie symbole est forme de deux nombres separes par un trait oblique,' Ie premiernombre representant Ie coloris predominant, par exemple 26/11 correspond Ii Bleu Wedgwood et Nair.

(d) Matiere utilisee pour la garniture interieureUn prefixe alphabetique ajoute au symbole du coloris indique la matiere principalement utilisee.

Simili-cuir: sans prefixe alphabetiljue; Cuir: prefixe 'H'; Tissu: prefixe 'C',

(e) InscriptionLa peinture, les coloris et les produits utilises sont indiques aux emplacements prevus sur la plaque de fabrication,

LACKIERUNG UND AUSSTATTUNGFur die Grundfarben und die verschiedenen Farbtone wurde folgendes Kodesystem aufgestellt.

(a) GrundfarbenDie neun Grundfarben haben folgende Nummern:1. Schwarz 4. Gelb 7. Lila2. Rot 5. Grun 8. Grau3. Braun 6. Blau 9. WeiB

(b) FarbtoneFur die verschiedenen Farbtone der obigen Farben wird eine zweite Zahl. beginnend mit 1, an denGrundfarbenkode angehangt. Es sind folgende Farbtone vorhanden:

Grundfarbe· 1. Farbton 2. Farbton 3. Farbton 4. Farbton 5. Farbton

Schwarz 11 Black

Rot 72 Pimento 82 Carmine 92 Magenta

Braun 23 Sienna 33 New Tan 63 Chestnut

Gelb 64 Mimosa

Grun 65 Emerald

Blau 106 Mallard 126 French 96 SapphireBlue

Lila27 Shadow

Blue

Grau

WeiB 19 White

Ie) Zwei FarbenWenn zwei Farben verwendet werden, wird dies durch zwei durch einen Schragstrich getrennte Kodes angedeutet,wobei die vorherrschende Farbe zuerst aufgefuhrt wird. So bedeutet z.B. 26/11 Wedgwood·Blau und Schwarz.

(d) Material fur die InnenausstattungAus dem Buchstaben vor dem Farbkode geht hervor, was fUr ein Material in der Hauptsacne fUr dieInnenausstattung verwendet wird.

Kunstleder - keln Buchstabe, Leder - Buchstabe H, Stoff - Buchstabe C.

(e) EintragungDie fur die Lackierung und Ausstattung verwendeten Farben und Materialien werden in die dafur vorgesehenenKiistchen auf der Inbetriebnahmeschild eingetragen.

SISTEMA 01 CODIFICAZIONE PER LA VERNICE ESTERNA E L'ARREDAMENTOINTERNO DELLA CARROZZERIAII seguente sistema di codificazione estato scelto per indicare sia' i colori fondamentali che Ie loro varie gradazioni.

(8) Colori fondamentaliCi sana nove colori fondamentali; i loro numeri sono :1. Nero 4. Giallo 7. Purpureo2. Rosso 5. Verde 8. Grigio3. Marrone 6. Blu 9. Bianco

(b) Gradazioni di colorePer coprire gradazioni dei colori di cui sopra, una seconda cifra che comincia con '1' e usata come prefisso ainumeri di cui sopra; il campo del codici ecome segue:

Colore1" Gradazione 2" Gradazione 3" Gradazione 4" Gradazione 5" Gradazione

Fondamentale

Nero 11 Black

Rosso 72 Pimento 82 Carmine 92 Magenta

Marrone 23 Sienna 33 New Tan 63 Chestnut

Giallo 64 Mimosa

Verde 65 Emerald

Blu 106 Mallard126 French 96 SapphireBlue

Purpureo 27 Shadow- . _. -- ._.

Blue

Grigio

Bianco 19 White

(c) Per due colori.I due colori sono indicati da due codici separati da una linea di frazione, dove il primo eodiee si riferisee al colorepredominante, per esempio 26/11 denota Blu Wedgwood e Nero.

(d) Materiali per I'arredamento interno.Lettere di prefisso sono aggiunte al eodice del colore per indicare iI materiale principal Ie dell'arredamento interno.

Stoffa imitazione pelle - nessuna lettera di prefisso, Pelle - lettera di prefisso 'H', Stoffa - lettera di prefisso 'C'.

(e) Specificazione.La vern ice ed i colori e materiali deWarredamento interno sono specificati nello spazio prowisto sulla targa diprovvigione.

CODIGO DA COR PINTURA EXTERNA E DOS ESTOFOSa sistema de c6digo que se segue foi preparado para cobrir a gama das cores basicas e das suas diferentestonalidades.

(a) Cores basicas.Ha nove cores basicas. cujos numeros sao:1. Preto 4. Amarelo 7. Roxo2. Vermelho 5. Verde 8. Cinzento3. Castanho 6. Azul 9. Branco

(b) Tonalidades da cor.Para cobrir as tonalidades das cores acima mencionadas usa-se como prefixo aos numeros acima indicados umsegundo algarismo comecado em "1 ". A serie de c6digo e a seguinte:-

Cor basica l' Tonalidade 2" Tonalidade 3" Tonalidade 4' Tonalidade 5" Tonalidade

Preto 11 Black

Vermelho 72 Pimento 82 Carmine 92 Magenta.

Castanho 23 Sienna 33 New Tan 63 Chestnut

Amarelo 64 Mimosa

Verde 65 Emerald

Azul 106 Mallard 126 French 96 SapphireBlue

Roxo 27 ShadowBlue

Cinzento .

Branco 19 White

(e) Cores duplas.As cores duplas sao indicadas como dais c6digos divididos por uma barra, sendo 0 primeiro c6d1go 0 das corespredominantes, isto e, 26/11 mostra azul 'M!dgwQod e preto.

Id) Materiais para estofos.Urn prefixo de letras junto ao c6digo da cor indica 0 principal materiai dos estofos.

Pergamoide - nenhum prefixo de letras, Couro - prefixo a letra "H", Tecido - prefixo a letra "C".

Ie) RegistoAs cores da pintura e dos estofos e os materiais usados sao registados nos espacos existentes na chapa de instrucoes.

METODO PARA EL CODIGO DE PINTURA EXTERIOR Y OECORACION INTERIOREI sistema de codificacion que se da a continuacion abarca los colores basicos y sus tonalidades diversas,

(a) Cohires Basicos.Existen nueve Colores Basicos, cuyos numeroo son los siguientes:1. Negro ' 4. Amarillo 7. Morado2. Rojo 5. Verde 8. Gris3. Marron 6. Azul 9. Blanco

(b) Tonalidades de Colores,Para referirse a las Tonalidades de los Colores arriba mencionados, se usa un segundo numero. comenzando en '1'como prefijo para los numeros que se dan mas arriba. La gama de c6digos es la sigulente:

Color Basieo ,., Matiz 2' Matiz 3°' Matiz 4' Matiz 5' Matiz

Negro 11 Black

Rojo 72 Pimento 82 Carmine 92 Magenta

Marron 23 Sienna 33 New Tan 63 Chestnut

Amarillo 64 Mimosa

Verde 65 Emerald

r-106 Mallard 126 French 96 SapphireAzul Blue

Morado 27 ShadowBlue

Gris

Blanco 19 White

(e) Colores Dobies.Los colores dobles lIevan dos c6digos divididos por una rava, correspondiendo el primer codigo al colorpredominante, por ejemplo: 26(11 es Azul Palido V Negro.

(d) Tejidos del Tapizado.Unas letras de prefijo anadidas al c6digo de color indican el tejido principal del tapizado,

Tel Cuero - Sin letra de prefijo, Cuero - Prefijo 'H', Pano - Prefijo 'C',

(e) Registro.La pintura y los colores Vtejidos usados en el tapizado se registran en los espacios provistos en la Placa de Encargo.

KODIFICERING AV UTVANDIG LACKERING OCH INVANDIG KLADSELNedanstaende kodificering anvandes till tackning av grundfargerna och deras fargnyanser.

(a) Grundfarger.1. Svart2. Rod3. Brun

4. Gul5. Gron6. Bla

. 7. PurpurB. Gra9. Vit

(b) NyanserTill tackning avovanstaende farger, anvandes ytterligare en siffra som ett prefix till ovanstaende nummer. Siffranborjar vid "1" och kodklassificeringen ar enligt foljande:

Grundfarger Nyans 1 Nyans 2 Nyans 3 Nyans 4 Nyans 5

Svart 11 Black

Rod 72 Pimento 82 Carmine 92 Magenta

Brun 23 Sienna. 33 New Tan 63 Chestnut

Gul 64 Mimosa

Gron 65 Emerald

Bla 106 Mallard 126 French 96 SapphireBlue

Purpur· 27 ShadowBliJe . . .

Gra

Vit 19 White

(e) Tvafargade.Vid tva· farger visas tva koder, atskilda med ett streck. med den fOrstnamnda koden representerande de overvagandefargerna t.ex. 26/11 anger Wedgwoodbla och svart.

(d) Kliidselmaterial.Prefixbokstaver vid fargkoden indikerar overvagande kladselmaterialet.

Ladermaterial - Ingen prefixbokstav, Lader - Prefixbokstav "H", Material - Prefixbokstav "C".

(e) Registrering.Fargen, inre kladselns farger och material, som anvants, ar registreradebestallningsnummerplaten.

angivna rubriker pa

VEHICLE AND UNIT SERIAL COMMENCING NUMBERS. VOGNS OG AGGREGATSSERIENUMMERBEGYNDENDE MED NUMMER AANVANGS-SERIENUMMERS VAN CHASSIS EN ONDERDELEN AUTONJA LAITTEEN ENSIMMAISET SARJANUMEROT SERlE VEHICULE ET ORGANE NUMEROS DE DEBUTSERIENANFANGSNUMMERN DER FAHRZEUGE UND EINHEITEN. NUMERI D'INIZIO SERlE VETTURE EGRUPPI NUMEROS PRINCIPIANTES DE VEICULOS E DE UNIOADES NUMEROS INICIALES DE.SERIEDE VEHICULO Y DE UNlOAD BORJAN AV VAGNENS OCH ENHETENS SERIENUMMER

1973 1974

D -. RHS. FH 50,001 . FH 60,001

I l HS. FH 50,OOll FH 60,OOll

m RHS. o'drive FH 50,0010 FH 60,0010lHS. o'drive FH 50,OOll0 FH 60,OOll0lHS. USA. FM 1 U FM 10,OOlUlHS. o'drive USA. FM 1 UO FM 10 ,OOlUO

All marketsexcept USA. 50,001 FH 60,001 FH

ID!O' . USA. markets 1 FM 10,000 FM

!

All marketsexcept USA.

USA. markets

FH 50,001 FH (from 1973)H (or L) E

FM 1 UE FM (from 1973)

All marketsexcept USA. FH 1 FH (from 1973)

All markets FH 50,001 FH (from 1973)

GROUP INDEX. INDEKS. GRUPPER. INHOUD-HOOFDSTUKKEN. RYHMAHAKEMISTO. TABLE DES SECTIONS.GRUPPENVERZEICHNIS. INDICE DEI GRUPPI. NUMERACAO DE GRUPO. INDICE DEL GRUPO. GRUPPINDEX.

09-45

09-34to

09-35

09-20to

09-32

09-44

09-04to .

09-19

09-37to

09-42

-_._..;;;..---..-+-----------+--------

09-47. to09-48

09-55

09-60to

09-61

09-49

09-57

09-63to

09-64

09-51to

09-53

09-58to

09-59

09-65to

09-67

GROUP INDEX. INDEKS. GRUPPER. INHOUD-HOOFDSTUKKEN. RYHMAHAKEMISTO. TABLE DES SECTIONS.GRUPPENVERZEICHNIS. INDICE DEI GRUPP!:•. NUMERACAO DE GRUPO. INDICE DEL GRUPO. GRUPPINDEX.

09-68 09-7009-71

to09-74

09-76to 09-80 ~, 09-82

09-7809-81

!~

10-84

10-23to

10-70

10-04to

10-21

10-74to

10-83

10-72to

10-73

09-83to

09-84

LLAR'~:A

PAGE INDEX. INDEKS SIDER. INHOUD-BLADZ IJDEN. SIVUHAKEM ISTO. INDEX. SE ITENVERZEICHN IS.f' • , ". • ."

INDICE DELLE PAGINE. NUMERACAO DE PAGINA. INDICE DE LA PAGINA SIDOINDEX.

09-04

09-07

09-10

09-14

09-05

09-08

09-11to

09-12

09-15

09-06

09-09

09-13

09-16

09-19

PAGE INDEX. INDEKS SIDER. INHOUD-BLADZIJDEN. SIVUHAKEMISTO. INDEX. SEITENVERZEICHNIS.INDICE DELLE PAGINE. NUMERACAO DE PAGINA. INDICE DE LA PAGINA SIDOINDEX.

09-20

09-23

. ~

09-26

09-29

09-32

09-2.1

09-24

09-27

09-30

09-34

09-22

09-25

09-28

09-31

09-35

• i


09-37

09-40

09-44

09-48

09-52

09-38

09-41

09-45

09-53

09-39

09-42

09-47

09-51

09-55

PAGE INDEX. INDEKS SIDER. INHOUD-BLADZIJDEN. SIVUHAKEMISTO. INDEX. SEITENVERZEICHNIS.INDICE DELLE PAGINE. NUMERACAO DE PAGINA. INDICE DE LA PAGIN~ SIDOINDEX.

09-57

09-60

09-64

09-67

09-08

09-61

09-65

09-68

09-72

09-59

09-63.

09-66

09-70

09-73


09-74

09-78 ~

09-76

09-80

09-81

09-77

09-82

10-10

10-07

10-04

10-06

09-84

10-05

09-83


Wi ri ngHarness

10-11

10-14

10-18

10-2110-22

10-26

BodyAssembly

10-12

10-15

10-23

10-27

Body Assembly(continued)

10-13

10-16

10-20

10-24

10-28

PAGE INDEX. INOEKS SIDER. INHOUD-BLAOZIJDEN. SlVUHAKEMlSTO. INDEX •. SElTENVERZElCHNlS.INDlCE DELLE PAGINE. NUMERACAO DE PAGINA. INOICE DE LA PAGlNA SlOOINOEX.

10-4310-4210-41

../~~

-,I 10-30 10-31

P ~

JOVO10-32 10-33 10-34

~~ J)~,.'0 .,.

10-35 ,,~ 10-36 10-37

~c:?"=

~c:=o ~

~. 10-38 10-39 10-40

PAGE INDEX. INDEKs SIDER. INHOUD-BLADZIJDEN. SIVUHAKEMISTO. INDEX. SEITENVERZEICHNIS.INDICE DELLE PAGINE. NUMERACAO· DE PAGINA. INDICE DE LA PAGINA SIDOINDEX.

10-45

10-48

10-52

10-55

10-46

10-50

10-53

. 10-56

10-47

10-51

10-54

10-57

10-59 10-60 10-61

PAGE INDEX. INDEKS SIDER. INHOUD-BLADZIJDEN. SIVUHAKEMISTO. INDEX. SEITENVERZEICHNIS.INDICE DELLE PAGINE. NUMERACAO DE PAGINA. INDICE LE LA PAGINA SIDOINDEX.

10-64

10-67

10-7010-69

10-66

10-63

Miscellaneous BodyFittings (continued) 10~73

~.~

10-65

10-62

10-68

10-72MiscellaneousBody Fittings

10-75 10-76 10-77 .

PAGE INDEX. INDEKS SIDER. INHOUO-BLADZIJDEN. SIVUHAKEMISTO. INDEX. SEITENVERZEICHNIS.INDICE DELLE PAGINE. NUMERACAO DE PAGINA. INDICE DE LA PAGINA SIDOINDEX.

10-78

10-81

10-84

10-82'WdIP ,OJ"'"'

10-80

10-83

1500 ENGINE-Cylinder Block

112907/3)

0144686(2)

101962

DP0610

159784

__---"500469(4)

___-"101022(4)

~101962

+HB1024132107

119758(2)

~ 144686

Q?DP0616

~ 0--"148353

\. "131786,,_--~.):.._;S:~_'s::S__:_ .. "118632

107246

\\

\III

1589¢1(4)

150022

32307

15n34

134933

"WL0210 "'-----Hl-_~61

... 118832 ---,J--l~~~

----4'"DP0514__-----==~~~

36234

121831~.

"144688~ ~

'* 144687

LISee Below--------j

"H61024 "'-------_AI!I501258

NOTEUSe Decarbonising Gasket set in conjunction with Conversion Gasket Set for complete engine strip

UKC0568 Engine Unit (short) 1offLI RKC0293 Cylinder Block Assembly 1off

Comprising items marked thus "520706 Decarbonising Gasket Set 1 off519215 ConversionGasketSet 1 off

e Alternatives

SPlTARE 1500 09-04 62992/2

1500 ENGINE- .Engine Plates and Sump

215350

•

HU0806131

MA0805('/

SPITFIRE 1500 09-05

114774

105321

GEG517

213863

WL020B(4)

HUOB05(4)

HUOB09(6)

62993

144975

J2~~~>--- 137811

GEG373

~143552181

157508(8)

_-------144648

144974

__------144688

~142649

~ ...... 132495141

\\_-~-

114774

__~_~1381761500 ENGINE - Cylinder HeadWF0508!21~-- . TN3208(2)

WP0008!21~ r\149348~

218755

153886(4)

109024

105120

109023

144973

109024

NOTEUKC1426 Cylinder Head Assembly 7.5:1 ratio 1 off

(Complete with valves, springs less studs)218139 Cylinder Head Assembly 7.5:1 ratio 1off

(less valves, springs and studs)501851 Jointin9 Compound AIR

(Cylinder Head to Cylinder Block)

SPITFIRE 1500 09-06 B2994/2

1500 ENGINE- Crankshaft, Piston, Conn. Rod, Flywheel.

" 149082

*149082

144195

@{159122/F159122/G

ill 155126(4)

~GlI40797(4)

~~$140798(4)

$155126(4)

'----$155125

119390

146485(4)

146454.(4)-----.J!I

1< 149081 14prsl

145275(004)

155357 217789

NOTE:516107 "Loclile" studlock AIR

:fMain Bearings and Big End Bearings are obtainable in the following undersizes:- .01 0" - .020"' - .030"When ordering please Quote Part No. and undersize required.

@Pistons are obtainable in the following oversize:- + ·020-EBPiston Rings are obtainable in the foUowing oversizes:- +'OlO:+'020';+'030~

Please Quote Part No and size required

<D Fitted up 10 Eng. No. FM12624

t1 Fitted from Eng. No. FMl2625

SPITFIRE 1500 09-07 82995/3

1500 ENGINE- Camshaft, Timing Details, Distributor Pedestal

100500(2)WP0018(2) PCOOO7(2)

HB0816

121530

104939(006)

125252(020)

104660

HN2008(2)

~ WL0208(2)

104861

35960

105131

312188

211126217790

WL0208(5)

WL0208(2) •

HU0807(2) ~' \ I

~~--"".

PT0803(5)

NOTE

SPITFIRE 1500 09-08 B2996/2

1500 ENGINE-Water Pump, Fan

HUOBOB~

WL020a--!

B0810

WL020B,~

56333

~~~GTS106

~L 03Qr---GTG1

138702

144297

101962(3)

138701

SPITFIRE 1500

. HB0818l---~-

HBOB19'V5'l-~-

HBOB22 _

../

<

1HN2008 (3)

216939

09-09

309141 (LIGHT GREEN!

WL0207(4)

:---- HU0706 (4)

B2997/2

\I

GFE119510451

(For use with GFE119 Purolator filter only)*'04963~

*'04964 ----__1

1500 ENGINE-all p"mp'OI(")~__~~~.~O J //u/ 0' 1'57~'4 SealingRing(foruseW~hA.C.DeIC0156581Filter)

G;;;5;1cf~r~A ,,~, ~_'''m~''"tJ ~ :;470/ .o~ /~;/f(~'7 .

157400 Sealing Ring (fOru~W1th A.P Products15658t Riter) . l ;/ /'I:;) \' -,1 i: ,', I

§J~' i~.'

I~ .\ .... ·......x,i'/ , '\\' .. ,.','L.I. i,, ' f) ~/ ." "~',,,, '\

# ".

132098(For use with GFE119 A.C. Delco filter only)

*504863

WL0207(3)

• 1553n

11------ HB0721(3J

*'56374 ~:::::- ~/"""~I

155370 _~_

217058 Oil Pump Assembly 1of'Comprising items marked"*

SPITFIRE 1500 09-10 82998

1500cc ENGINE-Auto-ignition vacuum pipes

---~--I'-0 I'

. ~--

152184 ~

1511 09

90/611428

Details on this illustration are fitted up to Engine No. FM10000UEfor future see illustration 09-12

I!J SPITFIRE1500 09-11-

82999/2

1500 ENGINE-Auto I~nition Vacuum Pipes, Thermostatic Vacuum Valve &Fuel Traps

505031

152184

NOTEDetails on this illustration are fitted from Engine No. FM10001UE• Fitted up to Engine No. FM10083UE• Fitted from Engine No. FM10084UE

151102

til SP ITF IRE 1500 09-12 83352/2

1500cc ENGINE-Emission Breathing Details

• Fitted up to Engi ne No. FM10083UE• Fitted from Engine No. FM10084UE

11 SPITFIRE 1500 09-13

.154213

.154212

B3000/2

U SA.only. Manifolds - . .1500 Englne-

149700

E . t CJ3014NOT 736 Alternative 0 FM 10000UE

~~~ed up to Engine ~~ FM 10001 UE. ed from EngIne'" Fill

SPITFIRE 1500

WF0524

149700

k-!l~'--UKC1846

09-14

58258(4)

WI'OO36(8)

100498(8)

(J)TKC0284

"'308086(J)RKC0158

8300113

1500 ENGINE-Petrol Pump

*520215

NOTE312343 Petrol Pump Assembly (Unrtac)520217 First Aid Kit (Un;tac type)

SPITFIRE 1500

~..•.. -/.

~

1 off (ColT1prising items marked thus '*)

09-15

*520216

'* Not Serviced

*138791

8300212

1500 ENGINE-Alternator Mounting

HU0858

156464

WP0017

HB0839

147483

SPITFIRE 1500

F r details see illustration 10 - 06

_----JN2168

147899

09-16

-----

B:JOO3J2

1500 SINGLE CARBURETTOR ENGINE-Air Cleaner. (U.S.A. only)

51B583121

SPITFIRE 1500 09-17 83004/2

1500 ENGINE -CarblJrettor· Assembly- USA.only

1449:J8

'" 313231

<D RKC0449

NOTEFor Carburettor details see illustration 09-19

'" 'ottoo up to Engine No FM10000UECD Fitted from Engine NoFM10001UE

215997

UKC0490

SPITFIRE 1500 09-18 8300512

1500 ENGINE-Carburettor Details (U.S.A. only)

519406

516980

<D RTC0768

512311

aT SERVICED

83006'3

6. Rtted up to Engine No FM10000UE<D Rtted from Engine No FM100D1UE

513688

518990

519050

@518842 Service Kit-'S'pack (red)Comprising @

@ 517767 Gasket, by pass valve.@ 516971 Washer, seating temperature compensator.@ 516972 Washer, ::-.ealing temperature compensator.@ 516005 washer. needle valve.@ 512311 'Q' Ring, float chamber sealing plug.@ 516980 Gasket float chamber.@ 516983 Seal. torottle spindle (2)@ 521153 Diaphragm (2)@ 517453 Needle valve.@ 516988 '0' Ring, damper.@ 516989 Lubricating pack.

09-19

517110

6.512281<DRTC0770

6.512282<D RTC0771

<D RTC04n

UKC0673

516948.

517767

517119(4)

513707~'~521153

516974(2)

518429(2)L--,i'!!17

518439518430

6. 519409<DRTC0472

SPITFIRE 1500

NOTE

*516434 Service Kit-:A:pack (yellow)Comprising **516005 Washer, needle valve.*512311 '0' Ring, sealing plug.

t 516980 Gasket, float chamber.

101962

* 14468612)

DP0610

112907{31

121398

*HB1024

*'44686

~DP0616

0-----*148353

__--*131786

132107

121217

~~.3~~~i.--o:tt~:=- *118832

__---*500468(4)

_----** 101022(4)

~101962

501258

158940(4)

ENGINE-Cylinder Block and Liner~lI129077

8146326

~ /WF0511

~WF0525

'" HB1024 ~-----.(J1;l

150022

*144687

151134

520244------1*118832 ------;:-(:---+------~

*DP0514---------:::~\1R'l~36234 ~

150022e=~:~A" :)Z..epX0805(2)~~

100501121

1300

loff Includes items marked '*

10ft

UKC0585 SHORT ENGINE UNIT(Will be supplied when stocks of 520709and 520710 are exhausted)e Alternatives

NOTE520709 ENGINE UNIT - 9 0 1 High CompresSIon 1off520710 ENGINE UNIT - 7 0'1 Low Compression loffNOTE - The above units are supplied less the following items;Water Pump and Fan Assembly. Distributor I Alternator, Petrol Pump,Oil Filter, Thermostat,Exhaust and Inlef Manitolds,Carburettors,Sparking Plugs and Breather Details520244 C~linder Block Assembly

eFitled up to l:ngine No.lIFitted from Engine No.

519215 GASKET SET, Engine Conversion520715 GASKET SET Decarbonlsing

SPITFIRE MK IV (1973) 09-20 83007/2

1300 ENGINE-E .nglne Plates and Sump

215350

215372

HU0806(3)

MA0805(12l)

NOTE'* Alternatives

SPITFIRE MK IV (1973)

HUOS09

500469

114774

09-21

143456

\105321

GEG517

" 213863*" 212006

=WL020S(4)

HUOS05(4)

HU0809(6)

83008

144975

145328(4)

109023 105322

144965(4)

104859

109024~&;';i{j~i>--- 137811

144974

~'42e49

~'32495141\I __--=-58923181 __-------- 144686

.., " Cj~-~-J?L.------144648"". \..J ..__ 101022

500469• SEE BELOW

~'06663(8)

~111870C~~, ~

157476:1

157229Cel

A·,57510(8)

1300

109024

105120

109023

144973

109024

NOTE .UKC1427 Cylinder Head Assembly-High Comp-ession

(Complete with valves and springs, less studs)UKC1428 Cylinder Head Assembly-Low Compression

(Complete with valves and springs, less studsl*218142 Cylinder Head Assembly-High Compression

(Less valves, sPrings and studs)*218143 Cylinder Head Assembly-Low CorT1JreSsion

(Less valves §lprings and studs)5Oj651 Wellseal,jointing compound A/R

(Cylinder head 10 block)

10ff

loff

loff

loff

e Fitted up to Engine No6. High Compression only.Hl Low Compression only.

only

SPITFIRE MK IV (1973) 09-22 83009/2

-1300 ENGINE-Crankshaft, Piston,Conn. Rod and Flywheel.

0<140797(4)

J"UKC1938(3)

201350

* 149062

306737

.6.144195

*"149082

~1441\* 149062

t{'55907/ F ]155907!G All markets

0<'40798(4)

0010155125(4)

~*149082 ~*149061(4~rs• 138529(8)

146454(4) , ~119369

*'49082

0155126(8)

119813(4) ___

146454(4)~d*'4906114prs)

0508878(8)

\0146485(4)

155357 217769 119390

NOTE*-Main bearings and Big End Bearings are obtainable in the following undersizes: - .010·, - .020".-.030"t Pistons are obtainable in the following oversize: +.020"'*' Piston Rings are obtainable in the following oversizes: +.01 0", +.020",+.030"

Please quote Part No. and size required.IJ. Thl1,Jst Washers are obtainable in the following oversize: + .005

Piston Assembly 155907 includes itemsmarkediDI

SPITFIRE MK IV (1973) 09-23 83010/2

1300 ENGINE - Camshaft,Timing Details, Distributor Pedestal

100500«)WP0018(2) PCOOO7(2)

/1~· 105114

HU080l (2) I ~

WL0206(5)

PT0803(5)

, 211126

217790

43752

UKC1110

312188

SP91B3(2)

105131

35960

104861

HB0816

121530

104939(006)+

125252(020)~

WL0206(2)

NOTEItems marked thus * are alternative fitment and are used as reQuired

SPITFIRE MK IV (1973) 09-24 B3011/2

1300 ENGINE - Water Pump. Fan.

19_---HBOBIO

311702 (ORANGE)

309141 (LIGHT GREEN)

.I/;}----- WL0207(4)

~ HU0706 (4)

156333

____ HB0818

,- HB0819

Aw.:~:---WL0208

138701

HU0808~

WL0208~

218939

HN2008(3)

NOTE

t NOr'f'l"la1 type Engines

@Special winter condition

SPITFIRE MK IV (1973) 09-25 B301212

"" 157414 (for use with A.C.Delco filter)

~ 157409 (for use with Automotive

Products filter)

1300

6104964-~_~_I

6104963~

6504863

6155370

NOTE217058 Oil Pump Assembly 1of f(Comprising items marked fj,J* Altematives to t


510451(for use with FJurolator filter,l

t 132098(for use with AJ:;, Delco filterJ

WL0207(3)

6155371

U~--

1-------HB0721(31

09-26

*'. 156581

t GFE.l19

63013

1300 ENGINE- Manifolds (All Markets except U.S.A.)

GEG648

NOTE"* 209776 Required when heater is not fittedt 212416 Required when heater is fitted8 Alternative to @A Fitted up to Engine No. FH59688E"* Fitted from Engine No. FH59689E

149699

WP0036(6)

100498(6)

• TD0861(21

308086

SPITFIRE MKIV(1973) 09-27 8301413

1300 ENGINE - Petrol Pump

*520214

*520215

NOTE312343 Petrol Pump Assembly (Unitac)520217 Rrst Aid Kit (Unitac type)


)'>

1off (Comprising items marked thus '*)

09-28

*520216

*" Not Serviced

*'38791

63015

1300 TWIN CARS ENGINE-Air Cleaner.

" HB0867 (41

WL0207

HB0709

NOTE*" 217822 Air Cleaner and Silencer Assembly 10ft


*217620

616011(2)

HN2007

". 151764 -_JI/ff/

09-30

/

*217636

83017

1300 ENGINE-Alternator Mounting

HU0858

156464

WP0017

H80839

147483

SPITFIRE IYIK IV (1973)

F detailS see iJlustr;ttjon 10-06

l--:--_---JN2158

147899

+I/

09"29

II,

83016

1300 TWIN CARB ENGINE-Carburettor Assembly and Pipes

6 AUD580F

:/yUD624F

/~157082 /'

100148(2)

114178(2)

511749 R.H.511750 LH

138892(3)

A12=e 125170

128262

216924 \.JL,...~....==-....._~

157068

6154280

f~#IIf'<:--"JI>'I

l

~'l~~HN 2009 (4)

NOTEFor Carburettor details see illustration 09-32

A Fitted up to Engine No, FH59688E8 Fitted from Engine No. FH59689E

SPITFIRE MK IV (1973) 09-31 6301814

1300 TWIN CARB ENGINE-Carburettor Details,

516242 Front516241 Rear

508017'(4)

~CUD410312)

~J..- 110679(21

511743(2)

5t683512J

,~

~108301(2)

II

520189(2)

- "-SUo AU D3308 (2),

108355(2)511726 (2)

...---~511709(2)

V~518882(2J

- '. ~ ~~.. 5~710(2)518886 (2) '"

. . 511724(2). ,,;-- ,511725(2)

518887 (2) . "-511723(2)' .

520188 Front518884 ~ear

503969(2)

520184 Front520185 Rear

515243(2)

108302161

108351161

511728(2)

\,--511712(2)

Not Serviced:--__~

511732 Front511731 Rear

518890(2)

108341(21

511713(2)

AUD9095 ---====,---------~111J

511738(2)-__~"",,~

51173712J-~---J'''\

518926(2)- ~./

AUD9257 Frontl_~ ~

II 516247 Rear r<D AUD9254(Rear)

.(j, Fitted up to Engine No. FH S96B8E<II Fitted from Engine No. FH59689E

SPITFIRE MK IV (1973) 09-32 83019/3

1500 ENGINE-Clutch and Slave Cylinder

~---155569

t517012

" 106084

t 516214

*510249~

@ "

Not Serviced

*515298 515299

NOTE214538 Clutch Cover Assembly 1 off

(Composing items marked thus t)519358 Facing Package, doven plate 1 off144716 Clutch Slave Cylinder Assembly 1 off515297 Service Kit (slave cylinder) 1, off

(Comprising Items marked thus*)

t516213t517010(3)

J t517011(3) "

~, "t501196(3)

t519669

146176(6)

SPITFIRE 1600 09-34 83020

1300 ENGINE Clutch and Slave Cylinder

0*'20128

*513063

'* NOT SERVICED

~ /HB0818'-r t 514698 (6)

ffit514714

NOTECD GCC134 Clutch Cover Assembly 10ff

(Comprising items marked thus t)b. 212037 Clutch Cover Assembly 10ff

(Comprising items marked thusm)144716 Clutch Slave Cylinder- Assembly 10ft

(Comprising items marked thus_)515297 Service Kit (Slave cylinder)

(Comprising items marked thus@)CD 515277 Facing Package,driven plate(not illustrated}6.RTC0273 Facing Package,driven plate(not illustrated)


cD Fitted up to. Engine NQ-FH 618246 Fnted from. Engine No FH61825

09-35 83021/2

ENGINE MOUNTING

'\152231(2) H80909(4)

122689(2)

136890

WP0008(2)

WL0208(2)-~c7-c,

HN2008(2)~

*209018 '-__-""""

" lKC0484

NOTESee illustrations 10-74 & 10-78 for Rear Mounting Details when Overdrive is fitted'* Fitted up to Commission No, FH6OOQO and FM10,OOW

b.. Fitted from Commission No. FH6OOO1 and FM10001 U

~-WP0008(21

~WL0208(2)

HU0805(2)

HN2008(4)

SPITFIRE MK IV (1973) &SPllFlRE1500 09-44 8302812

GEARBOX - Casing, Speedo Driven Gear

HBoe1S

119099

122569

TN320S

206175

~155660

217333

106437

HUOS07(2)

WL020S(2)

·157732

117510

83022/2

Gearbox Assembly 1Off}(Less Top Cover Extension and Hand Lever Assembly) All MarketsGearbox Assembly (Reconditioned unit) 1off except U.S.A(Less Top Cover Extension and Hand Lever Assembly)Gearbox Assembly (Over Drive Only) l0ftl(Less Extension Top Cover Extension and Hand Lever) Rtted up toGearbox Assembly (Overdrive only)-Reconditioned Unit 1 off (A Type Over'drive}(Less Extension, Top Cover Extension and Hand Lever)Gearbox Assembly 1Off

r(Less Top CoverExtension and Hand Lever Assembly) U.S.A onlyGearbox Assembly (Reconditioned Unit) 1off(Less Top COver Extension and Hand Lever Assembly)

Gearbox Assembly (Overdrive only) 1Off}Fltted fro(Less Extension, Top Cover Extension and Hand Lever) (J Type ~rive)Gearbox Assembly (Overdrive only)-Reconditioned Unit 1off(Less Extension, Top Cover Extension and Hand Lever)Gearbox Assemblies comprise details on this illustration and illustrations 09-38,09-39,09-40,09~41 ard 09-42

09-37

UKCI960

521069

520426

UKC1959

521067

NOTE521066

NOTE:

SPiTfiRE MK IV (1973) &SPITFIRE 1500

520432

521068

GEARBOX-Clutch Housing and Operating Lever

129358(2)

HU0809IB)

WL0208~1)

210449

500464

*122566

*DP0205

t1563368509860

PC0039rt/.D80914(2) ~~HN2009~~ WL0209

"" '" WPOOOB

132872

139563

HN200a(11)

WL0209(4).

HU0908(4) .

109182

129410 -----l]129412~

213032 G "-_..._.....

. GR8207

NOTE*Part 01 Clutch fbJsing Assemb~ 210449t156336 Alternative to e 509860

SPITFIRE MK IV (1973) & SPITFIRE 1500 09-38 83023 .

GEARBOX -Top Cover and Selectors

104449(6)

NOTE

*106489@148604 ------I136990~

158585

*'06489@148604~

106481

~

QJ;:;s1=~-158493c=--. j 107099

\----~106269

146240

108021

113868

520429 Top Cover Assembly 1 off

(Comprising all items on this plate except those marked thus t)*" Alternative titment@

SPITRRE MK IV (1973) & SPITFIRE 1500 09-39 83024

104433

GEARBOX- Mainshaft and Gears

156911

,r510818

~~~) WM0074

...,

155755

160018

~ 154479" UKC1450

'" 111423" UKC0933

1114231)147354

216614

156968

8L0018 (3)

ID4M5(3) \

"'I37948(A/R~

150328

Alternatives

NOTEt 155805 Washer (119";'121" Self Colour) AIR 1t 155806 Washer (1~Zl124" Green) A/R Between centret 155807 Washer (125";'127

u Blue) A/R' jbearing and drclipt 155808 Washer (128";'130·0range)A/R

'11-.111422 Washer Thrust (1S2N

/154")<=%"t149963 Washer Thrust (-1565t1585")~.131843 Washer Thrust (161"/-163")'1l.156084 Washer Thrust (-165:1 ·167" coloured Orange)

'UKC0769 Washer Thrust (169l171)

!J. Overdrive units onlyGil Fitted up to

() Fitted from

" UKC 0934 Washer Thrust (.198"1200"1"UKC0935 Washer Thrust (.201'1.203")() UKC 0936 Washer Thrust (.204"1.206")() UKC 0937 Washer Thrust (.207"/209")@ Fitted up to Gearoox No. only8 Fitted from Gearbox No.

SPITFIRE MK IV (1973) &SPITFIRE 1500 09-40 83025/2

GEARBOX-Constant Pinion, Countershatt and Reverse Shaft Gears

112654

500872

119893 (25) ~Jt:;:';~.,-/'

154829

"119891 (2)

113229

NOTE"* Part of Cluster Assembly 154829-1 Part of Gear Assembly 144580

SPITFIRE MK IV (1973) &SPITRRE 1500

""9891 (2)

~TN3209 ~

106448

09-41

106254

t 104420

144580

83026

p...... ~1'. ..

'1# r;

<h154238 ".

146303 (2)

118054

052516

4=-----''''-129120

/& ~~ 119262 '8155800

tM034 (steel) ,8155799., 155801 (nylon)

306152I

126607 () YZ3405(4) /"i:;;;;;;$;=;;;=~126754121~ .. ~::::::;;.=~o:::

$520999 __<i_~-1l>( .. 1~~'19573

~128373 .,

$155030~ .. =-___ 129119

119251". ct625536(4)-'f ~ct611177 \ I

119263~===-~ .. , 156~~ ..

119252--1 I £(:Q:J ~

138685--\.J ~ .. -

~2008(4)

ct WL0208 (4)------©

GEARBOX - Top Cover Extension and Hand Lever Assembly

NOTE

520543 Top Cover Extension and- Hand Lever Assembly$ 521031 Top Cover Extension and Hand Lever Assembly

Comprising all items above except those marked ()8155799 Bush ) ..e 155800 Spacer Alternative to 119262t 114034 Washer (Sleel) -2 off

(Use with 119262 Bush)* 155801 Washer (Nyton)-2 off

(Use with 155799 Bush and 155800 Spacer)

SPITFIRE MK IV (1973) & SPITFIRE 1500

1off1Off

+- Special order onlyffi Items marked thus are fitted to overdrive vehicles only

6. Items marked thus required when seat sensor device fitted@ Fitted from Commission No.

09-'-42 B3027/2

.~ ,

218982

219152

'305747

134400

*118977(8)

>123203(4)

NOT SERVICED

~_.~'HU0908(~

2'9037'

219153 ---f61Si~"

t.@TKC0b81 L.H.

152602

159733 132754 @NOT SERVICED ...L

[email protected].~

208943 @132435(:1) I (

• \~ \ i;' 132819

~

147223(2)-=~I4..olVf

I@136868

133122

209398

218684

155309(:1)

ZKC1256LHZKC1257 RH

CHASSIS FRAME AND SKID PLATE DETAILS

'09-45

NOTEt (Special orders only) -Not supplied as part of complete Chassis Assemblies"·

219056 Rear Cross member and Axle Mounting assembly (Comprising items marked @)403066 Chassis Frame complete filled up to Commission No- FH60000 and FM10000u (U.S.A,)PKCOO58 Chassis Frame complete fitted from Commission No. FH6OOO1

'" PKCOO53 Chassis Frame compietefilled from Commission No. FM10001U (U.SA)NOTE Olassis Frames complete comprise all items on this Plate except those marked + or *

'i\.,IJ,SAonlyl:!l-lJp to Commission No. FH60000 and FM10000Uttl From Commission No. FH6OOO1t::. From Commission No. FM10001U

SPITFIRE MKIV (1973) &SPITFIRE 1500 8302913

FRONT SUSPENSION - Upper Wishbone, Vertical Link, Hub119272(2)

138558(2)

WP0011(2)

211049 LH211048 RH

306603 RH306604 L.H

122126(2)

UKC0897

146479(2)

GHB11O(2) "7PCOO20(2)

119451(4)

WP0107(4)

"YN2908(4)

102690(2)

LN2211(2)

1off } Comprising:-Upper an.d Lower Wishbones,1off Vertical Link, Ball Joint. Stub Axle, Hub,t off Lower Fulcrum, Steenng Tie Rod Lever10ff and Brake Unit

NOTERKC 0257 Front Suspension Unit RHRKC0258 Front Suspension Unit L.H.

@515901 Front Suspension Unit R.H.(fitled with Grease nipples)

@515900 Front Suspension Unit L.H.(fitted with Grease nipples)

-"t Alternative to t@Scandinavian Countries and Special Orders onlyIl Attematives

.SPITFIRE MK IV (1973) &SPllFlRE 1500 09-47

102689(2)

B3030

FRONT SUSPENSION-Lower Wishbone,Road Spring and Damper.

140919 R.H.140920 L.H.

140894(2)

140892 (2)

130758 (2)

214144(2)

YN2907(6)

>----------WP0035(6)

217589 (2)'" 217591 (2)

206685 R.H.206686 L.H.

Not Serviced _-~'IJ,;;.:!'.

217590(2)0217618 (2)

123231~)---------->{

509260 (4) ------;

122137(2) -------""/

122022 AiR

r:,~HB0919 (4)

NOTE*- Alternative to t@ Heavy duty only

SPITFIRE MK IV (1973) & SPITFIRE 1500 09-48 83031

ANTI- ROll BAR

125481

II

~'~W~8

ir~j, i

I

125074

WP0110

YN2909

~~.- - - 155310

~~ . -, 155308

~i155307

are for Ho onlyme Market only

NOTEItems marked thu .Items marked thU~ ~ are tor Export

SPITFIRE MK IV (1973) & S . .PlTFlRE1500 09-49 83032

133070A!R WP0009(4)

,-:~~NOTE~cltems marked thus comprise the Pivot Bracket and Spring Assy 159640i Items marked thus are for use with Armstrollg Dampers only.:j: ltems marked thus are for use with Girli"g and Woodhead Munroe Dampers only.6. Assembly we 0479 includes Rubber Bush 117575

HB102712)

~WP0010(4)

SPITFIRE MK IV (1973) & SPITARE 1500 09-55 83036

_REAR AXLE ASSEMBLY AND SHAFTS

$See below

112429(8)~

131008(4)

136869

WP0110

@;;.@--YN2910

51150a(~ rW~

~'Seebelow\

_~@155928(2) @513800(2)

I!) 128469(2)

~'0458'(21

1:1

/ ~'2'860(4)1:1(a 121862<81

1:1 -- '"--'

NOTE*144101 Size -058- - -059- NeGolour AIR*144102 Size 059- -ow Yellow AIR*144100 Size -06rJ -Oaf Orange AIR*144104 Size '061" - "062' Magenta AIRt Fitted to Special Orders only alternative to 122115@155927 Outer Axle Shaft and Flinger Assembly. '(Consists of items marked @)@NKC0154RearAxle Centre Assembly 3'89;1 Ratio .. ,10fflFittedUP,to. .~UKC 1496Rear Axle Centre Assembly. 3-89: i Ratio: Recondlhoned UnIt loffJ For Details see llJustratlon09~52<ll NKC 0155 RearAxle Centre Assembly 3.89:1_ Retie 1off } Rned fromliB UKC 1497 Rear Axle Centre Assembly 3.89:1 Ratio Reconditioned Unit 1off Identified by Shield over Pinion Range Nut for details

see illustration 09-53

SPITFIRE MKIV (1973)& SPITFIRE 1500 09-51 - 83033

~1<114774

"SEE BELOW

(Ir *149648(2)

GHB105

tSEE BELOW

~~~~r-215537

"SEE BELOW134085 /-~.

, .....

ttSEE BELOW

139531

REAR AXLE CENTRE DETAILS Fitted up to Rear Axle No. It..----::5104O812380318\~ WL0207031 &--~"8826

@"'3953012J I.-----' . -:::1117952(2)~ ,~*117578(2)

~ ;#j~,. ~~o " 'll '"@SEEBELOW~ :,' ~ ~

~'34074~' ' l:l,

, '28572 2 III

~il"i , (\ 139532(2,), •. , ~'\lb "0375 \e \

EllSEE BELOW ~'340731429'9 '~Q ~",'34075 II

, 134075 " \

NOTEtTKC0220 Axle Casing assembly consisting-of itemS marked"*t518949 Hypoid Housing assembly consisting of items marked thust$156082 Shim .Q025"1.Q035} =1:-145918 Shim ·075'Ell,56083 Sh;m '0045'/'0055' . "'48099 Shim ·07r""54921 Shim '00921'0098' AIR "'459'9 Shim ·0765"'""54925 Shim '019' / ,021" , 145920 Shim '078'@148805 Washer {)41' ; '48100 Shim '079'@147249 Washer -029· -+ 145921 Shim '0795"@147250 Washer ,033' *'48101 Shim '080'@147251 Washer '03r " '45922 Shim ,081' AIR@147252 Washer ,043' AIR' *' 148102 Shim _082"@138440 Washer ·027" *145923 Shim ,0825"@138441 Washer ·035" *148103 Shim ,083'@138442 Washer ·039' .::1: 145924 Shim ·084'@134076 Washer '030'/'032' *148104 Shim '085'

; 145925 Shim {)B55'*148'05 Shim '086'SPITFIRE MKIV (1973) &SPITFIRE 1500 09-52

144255 Loctite Retaining compound} For crown wheel144259 LocquiC Primer .,.. bolts

t- 145926 Shim ,087"*145927 Shim ·0885"; 145928 Shim '090'; 145929 Shim '0915' AIR*145930 Shim '093'* 145931 Shim ,0945":I:- 145932 Shim -096'

t t 140790 Shim '030't +140791 Shim '010" (t t 140792 Shim '005", A Rt t 140793 Shim ·003'

() Alternative fitment

B3034

I

REAR AXLE CENTRE

139531<!lSEE BELOW

142919

t NOT SERV'GED--:~~~"l

----. UKC0764UKC0725

tSEE BELOW

21H5478

I... J

E1JSEE BELOW

*SEE BELOW

~ *'49648(2)

/

139531

NOTE*TKG0220 Axle Casing assembly consisting of items marked."*t518949 Hypoid Housing assembly consisting of items' marked thustEB 156082 Shim 'Q025"!'Q035"}' :f 145918 Shim ·075'EB1S6083 Shim '0045';'0055" A/R ::j: 148099 Shim '07TGll54921 Shim ·00921·0098' -t 1459'9 Shim ·0765"0154925 Sh;m ·019' ! 021· t 145920 Shim ·078"@148805 Washer ·04,- :t: 148100 Shim ,079"(!i147249 Washer '029" =I: 145921 Shim '0795"@147250 Washer '033" :f 148101 Stlim -QBU'@147251 'Nasher -037" .+ 145922 Shim -oar AIR@147252 Washer ,043" AlR +148102 Shim -082"@138440 Washer -021" t 145923 Shim -0825"@138441 Washer -035' :t 148103 Shim ,083'@138442 Washer '039" ::j: 145924 Shim ·084'""34076 Washer 030';'032' *148104 Shim ,085'*145925 Shim ·0855'

:f 146105 Shim ,086"SPITFIRE MKIV(1973) & SPITFIRE 1500 Ofr53

. 144255 Loctite Retaining Compound }

i1~m !~niF1e~~R*145930 Shim '093'*145931 Shim '0945"*145932 Shim ·096·() Alternative fitment

For crown wheelbolts

B3035

PROPEllORSHAFT AND ROAD WHEELS

143215(8)

t217384;'218944

t@217383f@TKC0770

17251 Prime Finish(SI151534 LimeGreen Finish(S)151535 Aluminium Finish(5)

.r~!'--Ll630624 (4)e 627579(4)

716180(4)

.633590(4)

312046(5)

NOTEItems marked thus ~ are alternative to items marked thus t,and will eventually be supplied for all replacements(0) Overdrive onlyLI Fitted uptoComm.ssion No. FM1840 and FHSI202e Fitted from Commission No. FM1841 and FH51203€) Chrome ) A .() Bare tv\etal Iternatlves

SPITARE MK IV~973)&SPITFIRE 1500 09-57 83037/2

STEERING - Wheel and Columns~ _

t\.

110461 ~- .'

502148(4)

A108977(8)~

502136(4)

108976(4)

NOTE1t Alternative fitmentI:::. Alternative fitmentffi For use when either 216449/2 or 219061/2 is fitteds US.A onlyI8J Fitted up to Commission No FM10000UlUSAJFH62644 AppfOX RHS and• Fitted tram Commission No FM10001U (U5.A),FH62645 Approx RHS ando Alternative Rtment+ Alternative Filment

,-~~_16OO3B

WP0008(4).-~YN2908(4)-"-\o

-156024(2)

____ 139386(2)

__ 133875(2)

SPITFIRE MK IV (1973) & SPITRRE 1500 09-58 83038/3

STEERING - Rack and Pinion Assembly

t128oo2

T 120948

t128oo4

<>t 12095@ _ 3(2) t 145108

@ ,153516(.004") cit 130032(.010")

@t130031(.002") - . .~ .....

t CS4020

-----

t 208058

--@tI42795(2)

Rack and Pin .Rack and P Ion Assembly R H S

RInion As }ack and P sembly L H S

(Norway a~~,~n Assembly L H S CompriSing ItemInner Sail JOI tweden-Fltted With G s marked thus tNorway and ~ Assembly 2 off rease Nipples)

Allernatlve F weden only CompriSing IlemIlmenllo 120955 s marked Ihus@

t 509537

"

NOTE305932305931308173

t 129961

"()

SPITFIRE MK IV (1973) &SPITRR. E1500 09-59 B3039

ACCELERATION CONTROL- All countries except USA

156533

, t 131289

t131492

t "G1307/4

143747

217465 LHS

156301 LHS

NOTE156216 Accelerator Pedal and Mounting Bracket Assembly RHS 1 off156217 Accelerator Pedal and Mounting Bracket Assembly LHS 1 offUKC1370 Accelerator Pedal and Mounting Bracket Assembly LH.S. (U.SA)

*' Common to assemblies 156216 156217 and UKC1370156342 Accelerator Gable AssemblyRHS 1off156344 Accelerator Gable Assembly LHS 1offt Common to assemblies 156342 and 156344t Fitted up to Commission No. only.e Fitted from Commission No. and future.

PCOOO5

___ /'" 57950

156300 RHS

~ Not Required U.SA.

til Fitted up to Commission No.:) Fitted from Commission No.

SPITFIRE MK IV (1973) Q9-60 83040

ACCELERATION CONTROL- U.S.A. only

156345 L.H.S.

PC0005(2)

~145891 L.H.S

NOTEFor Accelerator Pedal see illustration 09-60

SPITFIRE 1500 09 61

136835

83041

\

CLUTCH PEDAL

125217---\

...~@

HU0705/'(2) .... vL.:---':---'---~WM0057(4)

,. 156040 ) Seet 157192 Below

NOTE217431 Clutch Pedal and Mounting Bracket Assembly loff Alternative fitmentto 217949

(Comprising items marked"*)217949 Clutch Pedal and Mounting Bracket Assembly loff A1temativefitmentto217431

(Comprising items markedt)156040 Pedal Assembly, Clutch. Is a~ernativ. fitmen! to 157192

,.t 114438

,.t 150881

SPITFIRE MK IV (1973) & SPITFIRE1500 09-63 83042/2

BRAKE PEDAL

125217 ----1

*152823

i*105605 "UKC1276

NOTE217430 Brake Pedal and Mounting Bracket Assembly , off

(Comprising items marked"*)

*114438

*150881

/,

SPITFIRE MK IV (1973) & SPITFIRE 1500 0964 83043/2

CLUTCH MASTER CYLINDER

T:f.l06158

*106157

PJ8808

WP0008 PC0009

119583

-*106094

J---- h 106095

:; NOT SERVICED

t*109190

*106155

t*111979

,*510940

NOTEGMC 205 Clutch Master Cylinder Assembly loff comprising items marked "*508445 Service Kit loff compriSing Items marked t

SPITFIRE MK IV (1973) & SPITFIRE 1500 09--65 83044

BRAKE MASTER CYLINDER

*133581

"--

" -"-"

~\

h515182

146413

t---*NOT SERVICED

~t516222

~t516n1,/

//

/

//

/

/-/t*516225

//- t*516224

/-" /

'""./

t516219

t NOT SERVICED

t516218~_J'?

t510814

NOTE146422 Brake Master Cylinder Assembly 10ft. All markets except France and Benelux Countries

(Comprising items marked thus *)146423 Brake Master Cylinder Assembly 10ft. France, Benelux Countries and Special Order only

(Comprising items marked thus t)'* 515258 Service Kit, Brake Master Cylinder 10fttS,16227 Service Kit, Brake Master Cylinder 10ft

SPITFIRE MKIV(1973) & SPITFIRE 1500 09-66 83045

BRAKE MASTER CYLINDER - TANDEM

+ 517036--

+517037-

* 517033-_--\

'* Not Serviced

+ 517038

+517043

+ 517040

___+148156

'~*517039

NOTE517700 Service Kit (tandem master cylinder)517333 Service Kit (reservoir)213689 Brake Master Cylinder (tandem) Assembly L.H.8. Comprising items marked thus *(Fitted to special order only)

SPITFIRE MK IV ~973) & SPITFIRE 1500 09-67 63046

HANDBRAKE

PC0009

\PJ8807~

* 104737 TF2205

106036

121786

WL0202

104749

104750(2)

104749(2)

WP01,9

*132588

<:""

"~~ 131807(2)

l~~ ""HN2007141

PC0005121

WP0035121

131806121

ON2707(2)~"

*132588

OJ=\b=====:

--r-* 104740

NOTE132589 Handbrake assembly comprising items marked *Items marked e alternatives to items marked t.. Alternatives

SPITFIRE MK IV (1973) &SPITFIRE 1500 09-68 83047/2

BRAKES- Disc Front and Drum Rear

V5435 (4)

208715(2)

@123135(2)

@120124(4)

149623(2)//

1120134(2)

-@GBS544(4)

@504877(4)

213680R.H. L213681LH I -

@504878(4)

/111054(4)

159130R.H.159131 L.H.

WQ031O(4)

'~-~ ,~

CJ·\ \~.~ ,':~

~ \"'\~ " ",

('\ \

~ I,

NOTE219048 Rear Brake Assembly LH)compriSing items marked thus@219047 Rear Brake Assembly RH

@GV\C1202 Rear Wheel Cylinder Assembly 2off Comprising items marked tItems marked thus" are part of Caliper NO.146951-2

:fFor competition purposes only@ 508433 Service Kit, rear wheel cylinder 1off

SPITFIRE MKIV (1973) & SPITARE 1500 09-70 83048

HYDRAULIC PIPES- FRONT R.H.S. - Single System

~~t----:;YA0403(2)~3( 59380(2)

309702

1217B2

13H7428

309699

[o§)---WPOOO7

(j--HB071O

~ GBH202---~[1

HN2oo7~

WL0207~I !,CO

309701

100148

11f-----132365R.H.

·309700

59380 RH.S.

~~--516614

'/--- WN0709

YA0403 RH.S. ~--jl!l

GBH202

137048

SPiTARE MK IV(1973) 09-71 B3049/1

HYDRAUUC PIPES - Front L.H.S. - Single System

59380

309701

309706

__-309702

GBH202

YA0403

~

/'

309700

13H7428 --_m"'l

GBH202

SPITARE MK IV (1973) &SPITARE 1500 09-72 63050/1

HYDRAULIC PIPES- FRONT L.H.S.-Tandem System

308160

309700

309701

NOTE* Part of Valve Assembly 215104 (Not serviced)For right-hand front hose and details see illustration 09-71

SPITRRE MK IV 1973 & SPITFIRE 1500

~-309714

516614

'''-.,\.0-- WN0709

GBH202

83051/3

HYDRAULIC PIPES - Rear

309774

I~623312

~3

\136908

21H-5967(2)

59191(3]148820(2) * 59191 7

~"~8b

309773 '-

WN0709

516614

309703

309772

516614I

WN0709 I

-~~~--------7"

cx(f,.",11

Note,*Sweden only

SPITFIRE MK IV(1973)& SPITFIRE 1500 09-74 83052

, '

.' ...""

': ..f" •

. ~.

, '..~.

"

1~,:

'.'

PETROL SYSTEM - AII.Countries Except USA

600395

725117

312394

UKC3795(2)

~~5:::9::::::::::::::::::::::::===l1::J17~

209542

UKC3795«)

o UKC1764

t:. TL0008~_.'"

" 60142

154036

NOTE@ Alternatives[JGermanyonly/j, All markets except GermanyEB Alternatives

.SPITFIRE MK IV (1973) 09-76, ,

"', !

8305315

PETROL SYSTEM - USA only

217855

.•.••.....~...... 66:21721--)-,~-_ ..-~

1----718738

144938

~1_--725117

:1---155170

UKC3795(2)

155083

60142TL0008

209542

312394

_~:~-=~UKC3795(4)~ .. ,...~ "-

. '....'....

-.....:::::::::::::::::£:::2:;:\::::::::::::::::::::::===:3@==~~=··T0C~/UKC3795(4)

215999

149608

154036

NOTE516107 Loctite Studlock144259 Loctite Primer T

EEl Alternatives

SPITFIRE 1500 09-77 6305414

(U.S.A. Only)Loss· ControlrativeS YSTE~~-EvapoPETROL

158511

I

/215998.

Iii SPITF I RE 1500

59191 (4)

b

09-78

I

.83055/3

EXHAUST SYSTEM-(Fitted up to Commission No. FH60000 - All markets except U.S.A.and up to FM10000U-U.S.A. For future see illustration 09-81)

\\

\

~8GEX3372@ 312502Ell 312461

158575 (2)

\155249 (4)

WL0208(2)-

HN2008 (2)

:ft!:HU0808(2) ~

.--142281

HB0821

HB0822

WL0208

f .' ~141791V4~_WP0107

'''''~~-WL0208, ~HN2008

GEG701

515369(3)~~ "'.

~=~ ~~'"I

WL020a (3)

GEX1439r- ~

NOTEe All markets except U.S.A. and France@ U.SAonly@ France ,Gennany and SA.OR only.WiIl be supplied to other markets (except U.SA.) when stocks of GEx3372 are exhausted.

SPITFIRE MK IV (1973) & SPITFIRE 1500 09-80 B3056/3

EXHAUST SYSTEM - Fitted from Comm; 55.; on .No.FH60001 and FM1000lU (U.S.A.) "

155249

I;-008(2)

~ ~WL0208(2)'I -105290(2)

-·155249(2)

HNZ008(2) HN2008(2)105290(2~ /'

155249(2) ~

1585~ ,,'JJ1l _HU,0808

HU0808 .'. ~105290(2~ ~

W~0208(2) ell L .

142281

--WL0208 ~'''I~~~

138807

~HN2008-----

HB0820GEX7330

. / WP0017(!.

GEG701

515369(3)--. \' HB0821

WL"08pI ~WP0107 ~<5~y~,_,

GEX1439~

139827

,/

GEX7329

NOTEe All markets except U.S.A. and France(i) U.S .A. onlye France, Germany and B.A.O.R. only. Will be supplied to other markets (except U.S.A.)

when stocks of GEX3372 are exhausted.

~ SPITFIRE MKIV (1973) &SPITFIRE 1500 09-81 B3603

706844R.H.

RADIATOR AND PIPES

141475

WM0054(6)

WL0205....• 1/

:'(;j:.,~~fT-f't':It\, .' ..

PT050S

~'-HU0706(4)

~WPO007(2)

~FQ3405/4

~\~?B__-GRC114

I.,

GRH260

tCS4024(4)*CS4025(4)

HU0908(2)

HN2009(2)

HU0706(2)

A t CS4024(~)A *CS4025(4)

A 158308

;:,.160223(2)

706843LH

NOTEt Alternative '*b. USA only

219187 USAonly comprising details mai1<ed ;:,.TKC0924 U.SA only comprising details marked b.

• Fitted up to Commission No.m Fitted trom Commission No.

SPilFIRE MK IV (1973) &SPilFIRE 1500 09-82 8305712

TOOLS etc.

~--101089

---216915

156326

\

129833

122745

i

125505

I

NOTEi 149878

514302tGBF202

GBF201GBF203

@153245153317

8716032872579587160338725794

Special Oil. Rear axle lopping up 1 pI. tm.Gear box lopping up 1 pt. tin.

Fluid Brake and Clutch 16 oz. tin.S oz. tin.

32 oz. tin.Grease P.B.C 1oz. tUbe} For use with

" "4oz. tube brake pad shimsTool POUCh} AltemativesToOl PouchTool Pouch (U.SA) } AlternativesToo Pouch (U.SA)

SPITFIRE MK IV (1973) & SPITFIRE 1500 09-83 , B3058

PUBLICATIONS

t See Below ____

NOTE () Passport to Servi ceOperation Times Schedule 545232 (English Home)545204 D (Danish) AKD7759 (English European)545203 D (Swedish) 545224 (French)545205 D (Spanish) 545225 (German)545269 D (Portuguese) 545226 (F1 emi sh)545199 D (French) 545227 (Danish)545200 D (German) 545228 (Italian)545202 D (Dutch) 545229 (Portuguese)545201 D Italian) 545280 (Swedish)545272 D (English Overseas) 545235 (Spanish)545291 D Finnish) 545236 (Norwegian)t5451B9/73 Owners Handbook 545237 (Finnish)Spitfire 1500 U.S.A. only Owners Service Statementr~1 545233 (Eng1 i sh Home)~ SPITFIRE MKIV (1973) AND SPITFIRE i500 09-84

6 See Below

() See Below

* Owners Handbook545220 (English)545189 (U.S.A. Only)545190 (French)545191 (German)545253 (Flemish)545251 (Italian)545271 (Swedish)

L Workshop Manual545254 (English)545255 (French)545256 (German)545257 (Dutch)545259 (Italian)545292 (Dani sh

B3058A

e UKC2784

, ,-' .-.\.

508185

HU0708P(21

WL0207(4)

WP0007(2)

ELECTRICAL EQUIPMENT-Distributor, Sparking Plugs Leads and Coil .""150549

~~

~@j)eUKC~82_~.

o CJ p:-' '~-~ -~~0. " 150547 ~ .J - "" ~./::>'

~u e UKC2782 ~..:1 ~u ~-

.-J 1 r----... ~ , . ____.---- I

U U r~' ~ '/-' ~ =-"",A1~~ or.) A I

,O~:'r~~·~~ ~

~~~;~-~ ~ iFll .\JII 1/1 )1 -

% . l~ )r~~. /rF -~~ if&(J/~

I ® TKC~d9l

e UKC2781

/

134178 HN2007(2)

NOTE'XI TKC0419 Distributor Assembly Fitted to all markets excepi US.A@ 313232 Distributor Assembly U.S.A. markets only.t::. 517352 Coit and ignition lead kit.. N12Y USA onlye RTC0709 Coil and Ignition Lead Kit (may be used for all replacements)l:::.. Fitted upto Engine No. FH60977 and FM11468e fitted from Engine No. FH60978 and FM11469

Items marked e are interchangeable with those marked t:.. and may be used for all replacement!;.

SPITFIRE MK IV (1973) and SPITFIRE 1500 10-04 8305912

ELECTRICAL EQUIPMENT - Distributor Details

t+5ll844

H513993

t*511844

*520511t UKC1335

~ttGRAll0HGDC123

/HGSC104

t520340*520512

t 520342*520513

tt 513999(2)

t+ 513400

HHU0764

t 520341*520341 ~~-.I\

H511851

_---:;;;0"''';71* 134891

H511856~

t*511844--~

Not Serviced

NOTE+TKC0419 Distributor Assembly filled to all markets except U.S.A.t 313232 Distributor Assembly U.S.A. markets only


ELECTRICAL EOUIPMENT-Alternator (Lucas)

~+

~

517652

(~/~1·;~\~~...'/J"\1 ~ _

517651

NOTEt-ltems marked thus are part of Sundry part set 517237

For Alternator mounting details see illustrations 09-15 &09-29,219267 AllernatOrl6 ACR (Lucas)

517657

UKC1656

UKC1655

517653

UKC1659

UKC1658

517189(31


ELECTRICAL EQUIPMENT-Starter Motor

104549 (2)*514026t 501714

~~70391

---------,34174

e 501708(4)(1 Set)

e 501706

502210 (2)

PX0505 (2)-~ -:,' I

WL0205(2)~f'-/'" I

WM0055 (2) WE0605(2)

Not Serviced

57458

70391

+514025131570 AIR t 500927

~""*514024

,I

t501709

NOTE200535 Starter Motor 1 off70391 Sundry Parts Set 1 offItems mar1<.ed th\.lS '* are part of Lucas No. 25079.8. only.Items marked thus t are part of Lucas No. 25022 only.Die cast commutator end bracket items are marked ePressed metal commutator end bracket items are marked @

See mustration 10-00 for Inertia type alternative Starter Motor


,ELECTRICAL EQUIPMENT - Starter Motor

131570

519566

~

519811

Y" ~519566

~

\~,~

Not seI'Viced

519815

"\',

,,, ..'

\,,") , ,I\\ ,~., ' .

(@.>i

519566519813515020

501710

NOTE200535 Starter Motor, inertia type (Lucas No, 251496)

See iliustr.tion 10-07 for alternative Starter Motor

SPITARE MK IV (1973) and SPITFIRE 1500 10-08 83063

ELECTRICAL EQUIPMENT-Steering Column Switches, Flasher Units,Horns, Relay'etc;' .

.158459Hll58238

:iI 2189591:83 0 TKC1112

-- t See Below

WPOO23(4)

)WL0207C4)

a~.</~~I'(

" e See BelowHU0705 .

159761

I154180

+See Below

" 126792

eYA0403 <!l WL0203

<!l PTO~ffi;iil~©---<!l HN2053

r~,

r-f Q) WP0003 c::::~~'V'621967 RHS621968 LHS • ,

~EIl154577

Ir'" ,~"' W'O~'"6~ ._ ~Z3404 "f

@216112'(~1--~ "UlU(\ ~ TP0402(2)! ( .. ib--'i'i"'1l!'(

"WPOOO5141 :.~L-~"uJ@FU2578/8(2)

NOTE.158137/1 Horn, high note (Lucas)-RH 1off.158137/2 Horn, low note (Clear Hooter)-RH 1offt 158138/1 Horn. low note (Lucas)-LH 1offt 158138/2 Horn, high note (Clear Hooter)-LH 1offLucas and Clear Hooter Horns are interchangeable in car sets only.

e 156264 Bracket, horn mounting- RH 1Off} For use with Lucas horns onlye 156263- Bracket, horn mounting-LH 1offe 156276 Bracket, horn mounting-RH 10ffle 156275 Bracket. horn mounting~LH loff For use with Clear Hooter horns only

.AIternative to <D

• Filled up loComm.No. FM10000U (USA)FH 62644 Approx (R HS) andII F.ted fromComm. No. FM 10001U \USA) FH62645 Approx(RJi.5) and

III Left H,md Steering only. Also BAOR (RHS.)

@> Right Hand Steering only Also Left Hand Steering(except U.S.A from Commission No. )

o U.SAonlyt!. Not required Germany fromo Germany only() BAOR (RHS.)

" U.SA From Commission No. FM10001U

SPITFIRE MK IV (1973) and SPITFIRE 1500 10-09 83064/4

520101

Not Serviced

'*Not Serviced

" 517644

"" e

" 517643

131155

~J

150844

155430(2)

f517645

134747(2) 155906(2)

134751(2)

156307 RH156308LH

"i

EQUIPMENT - Windscreen Wiper

,156309(2)

*Not Serviced

NOTE

517621 Windscreen Wiper Motor (two speed) 1off(Comprising items marked thus '*)


613650

')

-8723297

61917

*618120

~/

612601~ \\

______-@604132

tWL0205

8PXOS08(2)

n·"-----C¥J- tHU0505

If

II!"i/ 'i

e566293(2) I I

/II

+WPOOOS

8622224(2)

@604146

~~

~2

(

t609172

ELECTRICAL EQUIPMENT-Windscreen Washer (All countries except Sweden)

t614126

NOTE8GermanyonlytNot required for Germ3ny*U.5.A. only

@Sold in feet

613650---L-1

SPITFIRE MKIV (1973) and SPITFIRE 1500 10-11 83066

.'. ELECTRICAL EQUIPMENT .;. Windscreen Washer (Electric) - Sweden only

514211

514210

EIl604132

613650(2)

'514213

NOTE211710 . Electric Washer and Bollie Assembly 1off

(Comprising items marked thus *")"' 514212 Motor, Pump and Cover Assembly 1off

. (Comprising items marked thus t)

(] Sold in feet

SPITFIRE MK IV (1973) 10-12

I.-_--+Not Serviced

'<514214

<514223(3)

B3J67

ELECTRICAL EQUIPMENT- Headlamps

@8H513266(2)

@GLU513(2)

149266(2)/

RTC0540(2)

@8n 515045(2)

!!

1t GLU114(2)8515046(2)

. 'i'GLU101(2)

l~8t 'i' 515218(21

NOTE514265 Headlamp Assembly L.H, Rule of the road. R.H.S. Home and Export517840 Headlamp Assembly R.H. Rule of the road. L.H.S. Except U.S.A., Canada and France.508793 Headlamp Assembly U.S.A. and Canada only. L.HS.514268 Headlamp Assembly France, Vietnam and French countries. LH.S.':'" 158858 Fuse Assembly,in-line, Dip Beam.Blue/Red 2 Off) Italy only.;:158734 Fuse AssembIY.in-line, Main Beam.Blue/White 2 off

2 off Comprising items marked thus "*2 off Comprising items marked thus t2 off Comprising items marked thus e2 off Comprising items marked thus@

SPITFIRE MK IV (1973) and SPITARE 1500 10-13 83008/2

1@518920

@520086t UKC1675

* 515061(2)

*@.:I:t605953(2)

I

~~$

" 515060(2)

1519364(2)

* 154049(2)

• 519365

@52008?t UKC1676

2 off U.S.A. only

1off )1off U.S.A. only.

Front Side/Flasher Lamp 2 off All markets except(Comprising items marked thus *) U.S.A. and,ltalyFrontSide Flasher Lamp )(White SideJWhrte Flasher) Italy only. Comprisin9 items marked thus t

Front Side/Flasher Lamp(Comprising items marked thus@)Side/Marker Lamp, Front RHSidefMarker Lamp, Front LH(Comprising items marked thus *)

*154049(2)

" 520083(2)

1515060(2)

155418

156561156562

159154

NOTE155416

*516304(2)

ELECTRICAL EQUIPMENT-Front Side! Flasher Lar:np and Front Side Marker Lamp.508762(6)-----@

1WP0003(6)

SPITFIRE MK IV (1973) and SPITFIRE 1500 63069

83070/2

T + 520088(2)(Ie 520095(2)

6RTCm6

$ 158567 Black R H$158568 Black L H

+«520089(2)()e520096(2)

t::.RTC1177

10-15

All market:s except U.s.A. from Comm.No.FH(Comprising items marked thUS6)

USA markets from Cornrn. NO.FM11633(Comprising items marked thus eJ)

NOTE216932216933

YZ3504(2)

~WPOI56(2)

,818771RH818761 LH

""'"~

Stop Tail Flasher Reflex and Reverse Lamp R.H.} All markets except U.SA and France (uptoComm.No.Stop Tail Flasher Reflex and Reverse Lamp L.H. (Comprising items marked thus..,)(Red Stop Tail, Amber flasher, White Reverse).

216934 Stop Tail flasher Reflex and Reverse Lamp R.H.} france Only (uptoComm.No.216935 Stop Tail flasher Reflex and Reverse Lamp L.H. (Comprising items marked thus t)

(Red Stop Tail. Amber flasher Amber Reverse).TKC0178 Stop Tail flasher Reflex and Reverse Lamp RHl U.S.A Only (uptoCommNo.fMf1632)TKC0394 Stop Tail Flasher Reflex and Reverse Lamp L.H. f (Comprising items marked thus e)

(Red Stop Tail, Amber Flasher, White Reverse).

TKC0941 Stop Tail Flasher Reflex and Reverse Lamp R.H.TKC0940 Stop Ta,l Fla,sher Reflex and Reverse Lamp LH.

(Red Stop Tail. Amber Fiasher. While Reverse).TKC0943 Stop Tall Flasher Reflex and Reverse Lamp RHTKC0942 Stop Tail Flasher Refiex and Reverse Lamp LH.

(Red Stop Tail, Amber Flasher, White Reverse).158563 Side Marker Assembly-rear (red) R.H.} U.S.A Only.158564 Side Marker Assembly-rear (red) LH. (Comprising items marked thus t9)

SPITFIRE MK IV (1973) and SPITFIRE 1500

He518042(2)

ELECTRICAL EQUIPMENT-Rear Number Plate Lamp

+519582

ti626859

t 518031 LH -----K

t 2158236. HN2005(4)

6. WL0205(4l .......-...:lln

/6. 159838(2)

6. GLB254(2)

61917

~....~..

~

I~-.. WM0055(2)\ WL0205(2)

9 I ~ (/"~...,...,...~==-~"'i!l. J

. . HN2005(2)

NOTE

718026 Rear Number Plate Lamp and Badge Assembly142002 Rear Number Plate Lamp Assembly, Italy only518270 Screws, Number Plate to Rear Bumper6. U.SAonly


1off (Comprising items marked thus t)2 off (Comprising items marked thus @)

Italy only

10-16 B3071/2

218815(Mile)218816 (Kilo)

515225

ElIU.SA<>USA onl)\ but WIll be Supplied for all markets when stocks of

625966 and 712913 are exhausted.() Italy only Frtted from Commission No. FH52644®6AOR (RHS.)mFitted up to Commission No. FM1()(X)()U~ Fitted from Commission No. FM10001U*' Proctor alternative to UKC2673

Wls.J.Clark altema~ve to UKC2064

159608

519325RHS

518314LHS~ ,

~1lI159893 . p/

\ /~ / ~158917

/ // // 148437

\\ (/ J... \~"';k>\\ /.. L

59492(6) ..

145890

8148630

61917

144370/0RHS138315/0LHS 144370/1RHS

l001~ W::6/1LHS ~PX0504

515002~jif t 156044

NOTE

+156044 Fitted on LHS. Cars onlye 148830 Fitted on Models with Dual Brakes or Hazard Warningl:> Parl of Assembly 218815 or 218816• Overdrive onlymSweden only

149137

154520/0 RHS156316/0 LHS

*156317/0RHS*158318/0 LHS

ELECTRICAL. 'EQUIPMENT-Facia Instruments and Switches145891(2) 155495


ELECTRICAL EQUIPMENT - Fuse,Fuse Cover,Courtesy Switch,etc.

~'-" --------." 9<D YKC09309<DYKC0933

<627740 RHS

~·FA"\

WL0205

9158509

~516506 -

627318

\

~295

GLB9B7

~

YZ3304

" 627733LHS• ® 90/559061 LHS/RHS

If, UKC1908

~100148

147777

/

NOTE ." Part of Main Harness AssemblyrnJ Required when Overdrive and/or Seat Sensor is fitted.9 U$,A,only

$ UKC1908 Required for Reverse Lighlt UKC0930 Required for Overdrive and Seat Sensor'* Fitted up to Commission No.FM10000(U.SA)and FH60000 other markets~ Fitted from Commission No. FM10001 (U.SA)and FH6OOO1 other markets<D Alternatives fitted from Commission No. FM62QOU approx (U.S.A)*" From Commission No. FM10001U

() YKC0930 Required for L.H.S. Ignition Illumination(MarKels other than U"SA)From Commission No. FH59261

4I20ft required U.S.A. from Commission No. FM10,001U


ELECTRICAL EQUIPMENT-Battery and Leads .

@518904

515999 RHS515997 LHS

@UKC1361 LHS.

{£. See Below

613155

142087,,: 601553

NOTE~.. 218167 Battery Lucas AlI/9 . 1off

EEl 514124 Battery- Lucas } 10ft 1515189 Battery- Exide alternative 10ft normal litment

M 141761 Battery- cold climate heavy duty 10ff

*Canada only@ UBA from Commission No. FM7563 and altemative filment other markets (LH.S.)(II Alternati..e to t

!:J. From Commission No. FM4756~ From Commission No. FM4757

SPITFIRE MK IV (1973) and SPITRRE 1500 10-20 63074/2

ELECTRICAL EQUIPMENT - Wiring Harness-etc.

UKC.1489 Body Harness L.H.S. (U.S.A.)

UKC.0856 Body Harness (Dual Level)

TKC.0944 Bodv Harness (Single Level)

Part No.

159939

59813131169511551503213511541145890611793125469612703508726313274

313273

Description

Borly Harness L.H.S. (U.S.A. only)

Screw, Sit battery leads to batteryScrew, Sit batterv leads to battervSleeve, wiring clips 'to frameSleeve, wirin9 clips to bodySleeve, harness to grille clipCleat, cable (Coil H.T. lead to'No.4 lead)Clio, cable, horn leads to radiator cradleClip, headla~p cables to bonnet hingeClip, lighting cables to chassisClio, temperature lead to alternator bracketMain harness R.H.S.

Main harness L.H.S.

No. perUnit

226

38II2I71I

Remarks

Fitted up to Comm.No.Fitted UP to Comm.No.U.S.~. only uo tpComm. No. FMlnOOOUFitted from Comm.No. F".l OOOlU~lternative to 131139Alternativ~ to 59813

Up to Comm. No.FH.62644 Approx.Up to Comm. No.

RKC.0569 Main harness R.H.S.

RKC.0570 Main harness L.H.S.

From Comm. No.FH.62645 Approx.From Comm. No.

313268

RKC.0352RKC.095915850115837114996756177508725153984515002PX0504WP0005WL0205HN2005144117

134301WN0708511481516064UKC.1363

Main harness L.H.S. (U.S.A.)

Main harness'\,L.H.S. (U.S.A.) Alts. RKC.0959 ll}Main harness] may be used for all reolacementsDiode encapsulated 1Gearbox harness L.H.S. (U.S.A.) 1Lead, extension, dual brake switch - L.H.S. 1Connector, double snap - Italv only 1Clio, cable, alternator leads 1Lead. extension. windscreen wioer and washer 1Clio, harness to engine bav valance 1Setscrew, clio to engine bay valance 1Washer, plain, clio to en9ine bay valance 1Washer, lock, cl i 0 to engi ne baY valance 1Nut, clip to engine baY valance 1Clip edge, main harness to front suspension 1

mounting bracketEarth bond, steering rack to chassis - R.H.S. IWasher, shakeoroof, earth bond, R.H.S. 2Lead, starter to solenoid - R.H.S. ILead, starter to solenoid - L.H.S. ILead, starter to solenoid' L.H.S. 1

U.S.A. only UP toComm. No. FM.10000UU.S.A. from Comm.No. P'.lOOOlUU.S.I\. onlvU.S.~, only

U.S.A. from Comm.No.

~SPITFIRE MARK IV (1973) AND SPITFIRE 1500 10-21 B3075/4

ELECTRICAL EQUIPMENT - Wiring Harness etc. continued

Part No .. Des cri pti on No. per RemarksUnit

159643 Lead, conversion, reverse lamp feed through

;1Ita lyonly, fitted

side lamps from Comm. No. FH.52624159644 Lead, extension, side lamp warning 1i ght160202 Lead, extension, hazard warning 1 B.A.O.R. only515409 Connector, double snap 1 Italy onlyZKC.0533 Lead, aerial jumper

11

UKC.2184 Lead, loudspeakerUKC.2211 Capacitor, suppression, coil U.S.A fitted fromUKC.2212 Capacitor, suppression, alternator Comrn. No. FM.10001U

~ SPITFIRE MARK IV (1973) AND SPITFIRE 1500 10-22 B4040

BODY AND FITTINGS - Body Assembly

Part No. DescriptionNo. perUnit

577713 BODY COMPLETE, SOFT TOP, PAINTED AND TRIMMED,INCLUD ING SEATS, R. R.8'.

1

577714 BODY COMPLETE, SOPT TOP, PAINTED AND TRIMMED,INCLUDING SEATS AND HEAD RESTRAINTS, R.R.S.

I

577719 BODY COMPLETE, HARD TOP, PAINTED AND TRIMMEDINCLUDING SEATS, R.H.S.

1

577720 BODY COMPLETE, HARD TOP, PAINTED AND TRIMMED,INCLUDING SEATS AND HEAD RESTRAINTS, R.R.S.

1

577725 BODY COMPLETE, HARD TOP AND SOPT TOP, PAINTEDAND TRIMMED, INCLUDING SEATS, R.H.S.

1

577726 ~ODY COMPLETE, HARD TOP AND SOPT TOP, PAINTEDAND TRIMMED, INCLUDING SEATS AND READRESTRAINTS, R.H.S.

1

577716 BODY COMPLETE, SOPT TOP, PAINTED AND TRIMMED,INCLUDING SEATS, L.R.S.

1

577717

577722

BODY COMPLETE, SOPT TOP, PAINTED AND TRIMMED,INCLUDING SEATS AND HEAD RESTRAINTS, L.R.S.

BODY COMPLETE, HARD TOP, PAINTED AND TRIMMEDINCLUDING SEATS, L.R.S.

1

1

All Marketsexcept U.S.A.

577723 BODY COMPLETE, HARD TOP, PAINTED AND TRIMMED,INCLUDING SEATS AND HEAD RESTRAINTS, L.R.S.

I

577728 BODY COMPLETE, HARD TOP AND SOFT TOP, PAINTEDAND TRIMMED, INCLUDING SEATS, LoR.S.

1

577729 BODY COMPLETE, HARD TOP AND SOFT TOP, PAINTEDAND TRIMMED, INCLUD ING SEATS AND HEADRESTRAINTS, L.H.S.

1 All marketsexcept U.S.A.

577737 BODY COMPLETE, SOFT TOP, PAINTED AND TRIMMED,INCLUDING SEATS AND HEAD RESTRAINTS, L.R.S.U.S.A.

1

577739 BODY COMPLETE, HARD TOP, PAINTED AND TRIMMEDINCLUDING SEATS AND HEAD RESTRAINTS, L.H.S.U.S.A.

1U.S.A. only

577741 BODY COMPLETE, HARD TOP AND SOFT TOP, PAINTEDAND TRIMMED, INCLUDING SEATS AND READRESTRAINTS, L.H.S. - U.S.A.

1

B3076

1

10-23

BODY COMPLETE, SOPT TOP, PAINTED AND TRIMMED,LESS SEATS, R.R.S.

~ SPITFIRE MKIV (1973) AND SPITFIRE 1500

577712

BOOY AND FITTINGS - Body Assembly

Part No. Des criptionNo. perUnit Remarks

577718 BODY COMPLETE, HARD TOP, PAINTED AND TRIMMEDLESS SEATS, R.R.S.

1

577724 BODY COMPLETE, HARD TOP AND SOFT TOP, PAINTEDAND TRIMMED, LESS SEATS, R.H.S.

1

577715 BODY COMPLETE, SOFT TOP, PAINTED AND TRIMMED,LESS SEATS, L.H.S.

I

577721 BODY COMPLETE, HARD TOP, PAINTED AND TRIMMEDLESS SEATS, L.R.S.

1 All marketsexcept U.S.A.

577727 BODY COMPLETE, HARD TOP AND SOFT TOP, PAINTEDAND TRIMMED, LESS SEATS, L.H.S.

1

577736 BODY COMPLETE, SOFT TOP, PAINTED AND TRIMMED,LESS SEATS, L,H.S. - U.S.A.

1

577738 BODY COMPLETE, HARD TOP, PAINTED AND TRIMMED,LESS SEATS, L.H.S. - U.S.A.

I U.S.A. only

57.7740 BODY COMPLETE, HARD TOP AND SOFT TOP, PAINTEDAND TRIMMED, LESS SEATS, L.R.S. - U.S.A.

I

Note:- The foregoing Body complete assemblies aresupplied less the following items:- FaciaAsh Tray, Steering Column, Parcel Tray,Brackets and cowl, Heater, Front and RearBumpers t Electrical Equipment, Instruments,Master Cylinders, Screen Washer

913831

913832

BODY SRELL, PRIME FINISR - R.R.S.

BODY SHELL, PRIME FINISH - L.R.S.

I

11 All marketsJ except U.S .A.

Note:- The above units are complete with Doors,Bonnet, Trunk Lid and Front Valance

913817

913818

BODY SHELL, PRIME FINISH - R.H.S.

BODY SHELL, PRIME FINISH - L.H.S.

1

I }

All Marketsexcept U.S .A.

Note:- The above units are Less Doors, Bonnet,Trunk Lid and Front Valance

913833 BODY SHELL, PRIME FINISH - L.R.S.(COMPLETE WITH DOORS, BONNET, TRUNK LID

AND FRONT VALANCE)

1 U.S.A. only

B3077

U. S.A. onlyI

10-24

913819 BODY SHELL, PRIME FINISH - L.H.S.(LESS DOORS, BONNET, TRUNK LID AND

FRONT VALANCE)

II SPITFIRE MKIV (1973) AND SPITFIRE 1500

BODY AND FITTINGS- Body Mounting Details

HB0912P(2)

~621101(2)

""""""-1-'"""'''~WMOO58(2)

\ .

!

'H:'--HB0828 (2)

WMOO58(2)

i'R:...-- WPOO19(2)

HBOB28P(2);j.

WL0208(2)

""WP0105(2) \

YW2908(2) --ti'''d

i-- HUOB10P(2)

et=WL02OB(2)

WMOO58(2) '"

_"" 613178(2)

~.

NOTE574245 Body Mounting Details Pack 1off

(Comprising all details on this Plate)

SPITRRE MK IV (1973) and SPITFIRE 1500 10-26 B3078

NOTE912846 Main floor Assembly 1off Comprising items mart<ed thus *707349 Cover Gearbox Assembly 1 off Comprising items marked thus t

<?*615980(2)

SPITFIRE MK IV(1973) and SPITFIRE 1500 10-27 B3079

715885LH715886RH

903132--~-~

706160 RH706159 LH

.~.603559(8)

NOTE815279 Trunk Floor Assembly Comprising Items marked thus "1:> USA only.@ Part of Assembly 725563/4e 3 off from Commission No. FM10001U:t= From Commission No. FM10001U

909662RH909661 LH

I 621112(2)\£1. /i@1:>615984(2)

1;;/, /

718717 RH718716LH

Ll725564 RH.Ll725563 LH

SPITFIRE MK IV(1973) and SPITFIRE 1500 10-28 8309012

715963 RH715982 LH

903098RH903097LH

908521

706423RH706422LH

809740 LH-LHS818785 LH-RHS

912979 LH-RHS912977 LH-LHS~~622160

&03559(14)

607621

607637(2)

607621

609785RHS609786LHS

615706

818786 RH - RHS818780 RH -LHS

912980 RH-RHS912978 RH-LHS

BODY AND FITTINGS -Dash Panels and 'A'POst621686 LHS 612981 RHS-LH

621706 LHS-LH

~.." .. I 62.1.7..0. 1 RH-IJ-IS. ~ ~.685RH-RHS

NOTE...Alternative to teU.5AonlyE9Canada onlyt:. Fitted from Commission No. FM1000lU


BODY AND FITTINGS- 'B' Post, Tonneau Side and Rear Deck Panels

814734

908908* 815262

.e 619099 LH I--H++--.--,,*e 619100 RH

813385 LH t----lJ813366RH

NOTE*U.sAonly813365-6 Includes items marked e.ll.Germanyonly., See illustration 10-40 tor details of Loudspeaker and Mounting(II Fitted from Commission No. FM10001 U

814733 613894 RH813893LH

I715821(2)

624733(2)1>631384(2)

-625189

SPITARE MK IV(1973) and SPITARE 1500 10-30 63082/3

BODY AND FITTINGS - Bonnet Assembly

*t908269

~@ 721493(2)@725525(2)

""\,€,\\---1 H 818626 RH"t818625LH

t909663LH*624557LH

*t911150

?/1" HWPOOO8

·*tJN2108(2) ~~

¥62(2)

*t909797 LH *t909351 LH*t911107LH

i

Jj f 6625187 624730

~/ ~t.631378

_. I /8625188 1 ' U"""'"..

iiI! \ ~~. I. 1iill 614006(2)

~ I.

*t911108RH

*t909352RH

t909664RH*624558RH

*t818872RH

NOTE913764 Bonnet Assembly 1 off Comprising items marked t913763 Bonnet Assembly (U.sA only) 1off Comprising items marked"I!. Germany only@ Ane,native filment in pairs.e U.SAonly

SPlmRE MK IV (1973) and SPITFIRE 1500 10-31 B3083

BODY AND FITTINGS - Bonnet Catch, Hinge, Attachment D.etails and Sealing Rubbers

~HN2007(2)

~ .

G):-WM0057(2)

/

/ /. / 569313(8)

J/~--'

WP0009(B)

608643 632030 (21

r1i ~ ~

~-~~~--o~ .. '~

607869 , ,

WM0068(4)

@U.SA only: From Commission No. FM1OCXJ1U


716200(2)

*911081

6725670 (2)

' ..~.•. '. HU0805(2)

' ...........•..'............ .1' . ~/2(2)',. HU08~

w~\rl.-:-"

BODY AND FITTINGS F- font Valanc F .e, rontal Grille, Engine Bay" I-----e va ance

:=:=-_-l-~" #~, .:mr;1r?:~",_~_.:@ "C~~ , ..J,j., Ilf'bI: ~-,.,* 911082. \ S\ I • '. WPOO28(4.»);61~5~699~_~(2~)-:§.1:::57:Z~C6l::2~)c:::·:::':::'::fc~

815392 ~ .' I tr~

,SPITFIRE MK IV (1973) dan SPITFIRE 1500 10-33 83085/2

BODY AND FITTINGS - Door AssemblY,Glass and Channels"'-'"

EIl726387

617078 (2)

613169 (14)

NOTE'" Part of Channel Assembly 706789 - 90@U,SAonlye Australia only. Fitted to R.H Door.6.Franceorny

612806(2)

SPITRRE MK IV (1973) and SPITFIRE 1500 10-34 83086/4

BODY AND FITTINGS - Door Handles, Lock and Window Regulator

621714 (2)

Note*For door lock details see Plate T13fl Germany only

~CZD 1698(4)'-----.-/

fL'"901364480 (4)

PT0504(6)

~~WE0605(6)

WPOOO7(8)/ __WL0207 (8)

~~ HU0704(8)

--l911272 RH1911271 LH

60/93760/9


I

BODY AND FITTINGS-Exterior Door Handle Details

576469(2)

NOTE

For exterior Door handle Assembly see illustration 10,35b. Germany only

I577473 (2)

724192 (2)

£I NKC0305(2)

£I NKC0306(2)

SPITFIRE MKIV(1973) and SPITFIRE 1500 10-36 . 83088

BODY AND FITTINGS - Door Seal and Trim Pads

727591 R,H,727581 L..H.

822559(2)-

632200(2)

~707931 (2) .

608516(16)

"*See Below

" 726461" 726451«726463"726453.. 726103" 726093" 726467H26457

Pad and carpet N;sy" door trim - RH}Pad and carpet N:.sy" door trim - u-tPad and carpet N;sy, door trim - RH}Pad and carpet N:.sy" door trim - LHPad and carpet N:.sy., door trim -RH}Pad and carpet N;sy., dOOr trim - u-tPad and carpet N:.sy" door trim - RH}Pad and Carpet Assy., door trim - L.I-I

Slack

Chestnut

Newlan

Shadow Slue

1 off1off1off1off1off1off1off1off

SPITRRE MK IV (1973) and SPITFIRE 1500 10-37 83089/2

Glass WIndscreen, Laminated, High Impact Interlayer (U.S.A.) ,Will be supplied to all markets when stocks of 908976 are exhausted.Glass Windscreen Toughened (Zebra Zoned)Glass Windscreen Laminated high impact interlayerSun Visor Assembly-Drivers side (Black) (also Sweden passenger side)When stocks of 630961 are exhausted 632089 "'II be supplied for all marketreplacements.

917248

~.

+.632091

*SeeBelow

909029

6823361'" 725931

917249

NOTE*917666

* 909328* 9089766823361

624691" ZKC0350

624711 RH624701 LH

816397

BODY AND FITTINGS - Windscreen Glass, Sun Visor and Interior Mirror" .RTC1006

6309~4.. . _630995c -c.. ---:-<i- __ - -._<-:0>:"" 630981

"'~"'~ Y630932(2) LH~

I WPOOO5(2)

(JJ PX0504(2)

,o~ .

t::. U.SA from Commission No. FM3807

SPITFIRE MKIV(1973) and SPITFIRE 1500 10-38

.632089 Interior Mirror Assembly(Comprising items marked ... )

• France only Also U.SA fromCommission No. FM10001U

$I Australia only

8309013

BODY AND FITTINGS-Facia Panels613186 815281 910961 R.H.S.

910962 LH.S.

WPOOO5(3)

t:.5ee Note

". LYl3304(4)' '.

WPOOO4(4)----1

~FJ2443J8(4)

509556(4)

-@631403

813271 R.H.S.813281 LH.S.

NOTE

918230 RHS 1 .918210 LHS Veneered Facings Assembly918220 LHS (Dual Br.akin9) (car set) Comprisin9

<918250 LHS (USA) details marked [).(;] 824560 LHS (USA)@ 824540 RHS (BAO.R)@ U.SAonlyt Part of Facia Panel Assembly 910961/2@ BAOR (RHS)only• Part of Escutcheon Assembly 726870.. (LHS) only


'*' Fitted up to Commission No. FM10000~ Fitted from Commission No. FM10001

10-39 83091/2

BODY AND FITTINGS - Facia Support and Parcel Tray .

709842

1:"----822558

WP0004(4)/ 509161(4)

FU25~19(~'~

IIII 813745 RHS..l """"'"'('~

500172(4)

503438(4) - --f',,<:>JlI

\728831

"l

~HU0504(~ . "WL0205(2) ~.

WPOOO5(2)~ • ';;;.JS

,,"YKC0288 " .. FU2544!8*ZKC0517 /

;/ 6*517783

~"696U"!-_fZ/"

J *RB5504(2

V

813753 RH.S.813754 LH.S.

WPOOO5(3)

HU0505(3)

HN2005(3)

WL~

~WP0005(3)

NOTE• U.S.A. and Canada onlyL:. Fitted from Commission No. FM10001U


BODY AND FITTINGS- Steering Column Support

608139_

209423510273(2)

kFC2803/9(2)

708479- ~

601597 _.

FN2044/9(2)

NOTE"* Sweden only.

708479

HU0708

" 156559154977

~155038 L.H.S. only

823488 R.H.S.823489 L.H.S.


BODY- AND FITTINGS-Heater Unit and Controls

625687 *614125 ..

NOTE910501 Heater assembly (p~rmanent Magnet Motor) 1off (including Items marked thus '* )

t 622229 Knob assembly@622228 Knob assembly


, .802638

-'~. ~WP0138(2) ~

WL0205(2) \HN2005(2)

152525

@J---- CJ3014

714434

~""'~i>-- WPOl3B(2)@-...WL0205(2)®---HN2005(2)

152523

11157802

*212416ffi212935

NOTE'* alternative*Not required U.S.A.E9 USA onlyIII Frtted up to Commission No. FH 60000 and FM10000U~ Fitted also to other markets from Engine No. FH59689E

BODY AND FITTINGS - Heater Hoses, Pipes and Demister Nozzles""'"' .

\:"~~r-~.;o::=-;g-~.~~~~~~~~_~"q;;~~6:22B12(2) = ~

SPlTARE MK IV (1973) and SPITFIRE 1500 10-43 63095/3

BODY AND FITTINGS-Trunk Lid; Spare Wheel Cover

-- 722675

630767(A/R)

t 517263(4)

I---'~' ri,.tHN2008(41~

WPOO05

" 729r30

PX0505P(ZI ~

- ~ ,619384~~--WL0205(2)

~. "V~/~-

911327

611444

$706807

612475(2)

~ 6632994(2)

~-WP0179(2)

/J;}r0159(2)

// I@)/, \~ \/

~\\\\\\I

NOTEItems marked t are fitted up to Commission No.Items marked '* are fitted from Commission No.Items marked EEl are fitted with Disc Wheels onlyItems marked @ are fitted with Wire Wheels only

6. GelTTlanyonly


BODY AND FITTINGS - Front Bumper

815276RH

'-e--

~/WPOOO9 ".

4 ~~ WL0209 ~______

• WL0209 F"( 631190"'. 1 WPOO09HU0907

HU0909P

If---- 911140

WPOOO9

jWL0209

HUQ907

I W WL0221 (2)

"~ HU0707D(2)

~HU0909P

~~----------- WL0209

WPOOO963190

"WMOO57(2)~ \

"WL0221(2)~'--@"HU0705P(2)~

., 624619 R.H."624616 L.H.

HU0705 -

\WL022111

WMOO57

815277LH

NOTE@ U.S.A.only. Fitted from Commission NO.FM10001U


WP0139

HN2009(2)

,


715702 RH

HU0908(2) ~ ~

/ HU0912

HN2009(2) WL0209

WPOO09

914698

10-47

WL0209(2)

HN2009

7<WPOOO9 WL0209

83098

1;;:00WP0009 WL0209

WL0209(2)

WL0206

BODY AND FITTINGS-Rear BumpedU.S.A.Type Markets Only) -WP0139 631190

/@WPOOO9(2)

@WL0209(2)@HU0907(2)

@634728(2)

j @WP0009(2)@WL0209(2)

@ZKC0864(2)

~ @HU0706(2) Ll715702RH- ~1L/.\

~ \ J~@:~0~~~l2) @HU0707PHU0908(2)/t"i / - rU~\~~@W~0209(2)@WMOO57(2)HB0914

~ ~ / ~ WL0221(2)I~ \ ~@631190(2) LlHN2009(2)

') "~~/@730530LlWP0009~ '. . @WPO009(2) 632300

@WPOO09(2F- ~ ~ /@HU0915(2)

@HB~" ~\ . w ~ // :~~:m~~~

@WPOO07~0@'Zy~ ~~@WL0207(2) ~o;D~~~~--_.- a

@HN2007(2) /- 824794LH-"---=-""" '\:,@HU0708P @WL0207(2) 824!95RH~ "'>,J \'\\

WP0139 @WMOO57 2) ~-----_.lJ631190 \ WL0208 ~

lIHU09~)~ I/HU0806 ~@:~~~:8~ ~t LlHU0908(2) @HU0805

lIWL0209(2)'(s)' ~L0209(2).;---<0 ~WP0009(2) Ll715701LH

LlW~~0009(2)::~ ,~g~'::~:::HB0914"' r

"LlHN2009(2) ~'<!\ WP0009 , ~;

~WPOO09

){~HN2009WL0209

lIUp to Commission No. FM10000U@ From Commission No. FM10001U

SPITFIRE 1500 10-48 B3099/4

BODY AND FITTINGS-Tonneau Cover

G1 See Below

NOTE577264 Tonneau Cover Kit-White-RHS577265 Tonneau Cover Kit-Black-RHSNKC0310, Tonneau Cover Kit-White..:.R.H.8.} R.H.S. \9hiclesNKC0309 Tonneau Cover Kit:- Black- R.HS. with Head Restraints.577266 Tonneau Cover Kit - White - LHS577267 Tonneau Cover Kit - Black -LHS

NKC0308 Tonneau Cover Kit - While - LHS (USA only)NKC0307 Tonneau Cover Kit - Black - LHS (LISA only)

Ell 822459 Tonneau Cover Assemb~ (White) - ~HSffi 822451 Tonneau Cover Assembly (Black)-AHS\ll 822469 Tonneau Cover Assemb~ (White) - LHS<J) 822461 Tonneau Cover Assemb~(8Iack) - LHS

~Q -;~"

565756

,

9-1@ZKC0751(15)8IaCk

~ .2 @713481 (15) 81acke 713499 (15) White

-----rr~ e ZKC0759(15) White713501 (15) -W

Comprising above details

822499 Tonneau Cover Assembly (White)} RHS. "'hicles822491 Tonneau COver Assembly (Black) with Head Restrain't$.

e 822509 Tonneau Cover Assembly (White) LHS (U.S.A.)Ell 822501 Tonneau Cover Assemb~ (Biack) LHS (U.S.A.)*' 713511 Stud Black Tonneau Cover to doort 713519 Stud White Tonneau Cover to door@ Alternativese Alternatives!J. Alternatives


627362 (14)

1-815042

;f"

( 613886 :4)

----715695

/j815137LH815136RH

*724028LH*724029 RH

NOTEItems marked thus *" are for Germany only""Not required when Hard Top is [email protected]"Ali markets except U.S.A Also required for U.S.A (U.K Oelivery)


BODY AND FITTINGS - Hood Sticks

814828 621465(2)

'\I \ I

715870 \' II \ / 624580( 18)

624569(18)/~ @i:624583(18) / / - \/ ~,~'"

624599

815274

715872

715869-

-//624569(2)~ffQ)i Gl"

624583(2)~ P1r/ -

. 624580(2)

JN2107(2)

715867

715871

NOTE911149 Hood Frame Assembly. Comprising all items above.NKC0342 Hood Kit (Black), Comprisin9 all items on illustrations 10-52, 10-53and 10-54NKC0343 Hood Kit (Whit~). Comprising aU items on illustrations 10·52, 10-53 and 10·54

SPITFIRE MK IV (1973) and SPITFIRE 1500 10-52 , 83102

BODY AND FITTINGS - Hood Cover

715842

575813

'\l:> 713491(2)

l:>ZKC0751(2)

713501(2)

723350RH723349LH

~-- ~f"~""l:> 713491 (8) Blacke 713499(8)White

1\ ZKC0751CSI Blacke ZKC0759(8)While

~.~

~ ~.O574437(3) ~\L

713511(3)Black • 631771(3)713519(3) While

509563(3)

71350~ ____

~l:> 713491 (5)

l:>ZKC0751 (5)

NOTE822371 Hood, Sewn Assembly -Black. Comprising ali items above8223711 Hood, Sewn Assembly - White. Comprising ali items above

.6.Attemativese Alternatives

SPITFIRE MK IV (1973) and SPITFIRE 1500 10-53 B3103l2

713038RH

713036

BODY AND FITTINGS - Hood Attach~. ment Details

713037 LH ------- - ~-::?----713531(6) -". ~ •

"'"''''' §"~,,. ~\ _~!~,o

. J ,,,_,, l,"-~~ /

713511(5) - " ~~23223LH )

'" ,,"""'"~ 'Ii._~.~.v-"" ~19'(T ~I ~ l.; 7 /j ~/H.<m;,,,

6248\18(4) ,II j/0~;' \ .0// )"-'" .~ /"""'"1 ~ ~ ~ ---* 621758(2)

.____-, , v'l,; ;1 ~d.,~ \1\, ~ f)' ~* WPOl19(2)_ II 1 1 .--'~~'"f: j§} T

. / 500057(4) \\:rJ\\ ~.'~-~~:;,oo,o ""~~~ --"'_o

to __L-510524(4

1\\ / [J

_ ' \, _ _ ' 'W="(2) 512381(4), ' ' / ~"~.__"'~ ~517145 (4)

~~'---;. 561210(2) r ~.lJ ~Q t630669(2) ~,,y' ~cy/ (,

_ _ _ O. 'M~

713511(6)~-/' 0713519(6)~~ ~ 1~5 5259(6)

~ 21 ''''M~~~ "'WHO' "~H" ""'~~624546 H' 713519(2)

624545 HandleAssembly RHI'~::::~-----~-------------andle Assembl 'Parts m . y LH Comprisin9 it

t Germany only arked t are required ems marked thos *when hard top to soft conversion is fitted


BODY AND FITTINGS - Hardtop Assembly

632234

726544"

Ell NKC0341

_ 57443~~

71351~3) 1}~

\~~45(6)

\632254 R.H.632244LH.

NOTE'NKC0344 Hard Top Kit (Beige headlining) 1off Comprising details on illustrations 10-55, 10-56and 10-57

\B Hard Top Assembly,Primed.complete with beige headlining 1off COmprising all items aboveWhen Hard Top Kit is fitted it is recommended that the appropriate Hood Stowage Cover on illustration 10-61 is also supplied.


BODY AND FITTINGS-Hardtop Glass and Sealing Rubbers

*574133(2)~

613962

911040

-I*' 624860 RH1*624861 LH

~575639 (5)

815498

*574132(2)

~* 624812RH* 624811 LH

*519912(4) ---,

~ --=-"

629564

~6(8)

818811 RH ............=_818801 LH

NOTE821165 VentAssembly,Rearauarter-R.H. 10ff}

1offAssemblies include ite.ms marked *821164 Vent Assembly, Rear~uarter-L.H,

SPITFIRE MK IV(1973) and SPITFIRE 1500 10-56 83106

BODY AND FITTINGS-Hardtop Attachment Details

WP0125 (2)'-~"

*624874RH*624873LH

*514777 (2)

~{~*HU0708D*500227 (2)

NOTEt Required when soft top is also fitted"* Required when soft top hood is not fitted

J------::7624825 (2)

~624818(4)

c!---- 503438(4)

~----'----'510524 (4)

rt624818(2)

~ ~ t503438(2)

~ --t510524(2)

_Q\ ~~'~t512135(4)715026 RH L_ 'l,d1 t510397 (4)716025 LH , d~

r t503439(2)t624720(2)-- ~

-4 ~t624817(2)Itjl/~

t 510524(2)


BODY AND FITTINGS- Front Carpets and Dash Side Trim

718071 RH (RHS)718091 R.H.(LH.S.)

:21(4)

~563769(4)~ Ell 554517 (4)

EIl553252 (4)

822871

~630321 LH

718061 LH (RHS)718101 LH (LHS)

EIl63 271

726491 R.H.

/*t569254(3)

~*tWP0126(3)

~*t554517(3)

r---56121O(3)

~610624(3)

726561 RHS726571 LHS

* t 569254 (3)

561210(3) ~~\ ~'~tWP0126(3)

610624 (3) ,y '"~. H5545l7(3)

632521 R.H.

630331 RH

NOTE

*Part of Carpet Assembly 718071tPart of Carpel Assembly 718101

*tCommon to Assemblies 718071,718061,718091 and 718101@Partof Assembly 726561 and 726571EIlPart of Assembly822671


BODY AND FITTINGS -Rear Quarter and Seat Pan Trim

609716

634263 (New Tan) lJ-i632187 (Shadow Blue) lJ-i6321B3 (Cheslnut)...H.632181 (Black) lJ-i

633093 (New Tan) L.H632157 (ShadowBlue)L.H632153 (Chestnut)LH.632151 (Black) L.H

509279 (6)

/j> ""'=~:::-.~D24152 (6)

730923 (New Tan )RH726647 (Shadow Blue) RH726643 (Cheslnut)RH726641 (Black) RH I'> FU2544f:~51443~ 5~61 (7)~.. 509141 (7)

WPOOO2(2)~~

~713521 (2) ~

509279(6) ~ \) \)

COl .. WE0605 (7)

jjD24152(6)~~ ~ , .. WP0113171713511 (Black) (2) T713519 (While) (2) .. FZ3404/4 (7)

633103 (New Tan) RH632167 (Shadow Blue) RH632163 (ChestnutjR.H.632161 (Black) RH

634273 (New Tan) RH632197 (Shadow Blue) RH632193 (Chestnul)RH.632191 (Black) RH

821753 (NewTan)82261 7 (Shadow Blue)822613 (Chestnut)822611 (Black)

III 905654 730913 NewTanLH.726637 (Shadow Blue) lJ-i726633 (Chestnut)LH.726631 (Black) lJ-i

NOTEt:::.. Alternative fitment in sets to items marked -

I8l France only.

SPITFIRE MK IV (1973) and SPITFIRE 1500 10-60 B3109/3

BODY AND FITTINGS - Hood Stowage

*713511 (2) (Black),,713519 (2) (White)

/:). Alternativese Alternatives

6:11685

11---627021

#";:P'"

il!kC0751 (2).Black~e ZKC0759(2)Whitet. 71 3491 (2) Blacke 713499(2) White

~

~13491 (13) (Black)

713499 (13) (Whlte)---Q

'\ ~713501 (13)

10ff

• 625293 (2) (New Tan)• 632067 (2) (Shadow Blue)• 632063 (2) (Chestnut)" 632061 (2) (Black)

tSeeBelow

627~

621685~

Hood Stowage Cover AssemblY (for use with soft top)

NOlE

t B21603 NewTan }t 822407 Shadow Bluet 822403 Chestnutt 822401 Black

...O(.---~71351'(2) (Black) -'lI(7j§J-,---=::::::z,.,...713519 (2) (White) /

WPOI09(2)

*821623 New Tan }'" 822437 Shadow Blue"822433 ~hestnut Hood Stowage Cover AssemblY (for use with hard top)*822431 Black

SPITFIRE MK IV (1973) and SPITFIRE 1500 10-61

1off

8311012

BODY AND FITTINGS-Seat Assembly (without Head Restraint) All Markets except U.S.A.and Australia

.625139(2)

~.918571R.H.} Black91B561L.H.918573R.H.} Chestnut91B563L.H.922533R.H.} New Tan 1---922523L.H.91B577R.H.} Shadow918567L.H. Blue

NOTESeat Assemblies comprise details on illustrations 10-62, 10-64, 10-65, and 10-67.. Required when Head Restraint not fitted

II SPITFIRE MKIV AND SPITFIRE 1500 10-62 B3111

BODY AND FITTINGS~Seat Assembly (with Head Restraint) U.S.A. Australia and Japan

For detail s seeillustration 10-66

Leathercloth"'918781R.H.B1ack*918783R.H.Chestnut*922743R.H.New Tan"'918787R.H. Shadow 81 ue

~ +918501L.H.B1ack~ +918503L.H.Chestnut~ +922463L.H.New Tan~ +918507L.H.Shadow Blue

@91851lR.H.B1ack918513R.H.Chestnut

@922473R.H.New [email protected] Blue

(l) +918771 L.H.B1ack(l) +918773L.H.Chestnut(1) +922733 L.H .New Tan(1)+918777L.H.Shadow Blue

NOTE"'U.S.A.only-tU.S.A. and Australia & Japan

. I!' Austral ia & Japan onlySeat Assemblies comprise details on illustrations 10-63 to 10-67 inclusive

~Not required U.S.A. after Commission No. FM10000UwUSA from Commission No. FM10001U, but may be used for Australia &Japan also.

Iii SPITFIRE MKIV'(1973) AND SPITFIRE 1500 10-63 B3112/3

BODY AND FITTINGS-Seat Frame and Squab Assembl ies (All Markets)

CZA4713(2)

816809(2)

816810(2)

816801(2)

816811 (2)

~;;;;:-----..:::::~W* 913748 RH*913747 LH

~~610520(8)~ 6~112)

618775(4)

"OTE, Frame and Squab Trimmed Assembly(Comprising details above and on illustration 10-65, Part of Seat Frame Assembly 916401/2

Leatherclotht:, 918691 RH}t:, 918681 LH Blackt:, 918693 RH}t:, 918683 LH Chestnutt:, 922653 RH}t:, 922643 LH New Tant:, 918697 RH}t:, 918687 LH Shadow Blue

SPITFIRE MKIV (1973) AND SPITFIRE 1500 10-64 B3113

BODY AND FITTINGS-Seat Squab Details (All Markets)

fY

~(:.

-------- CZA4500(2)

-CZA4263(2)

624894R.H.· /

624B93L.H. r

624888R.H.624887L.H.

917600R.H.917599L.H.

Leatherc10th727511R.H. Black727501L.H.727513R.H. Chestnut727503L.H.729633R.H. New Tan729623L.H.727517R.H. Shadow Blue727507L.H.

II SPITFIRE MKIV AND SPITFIRE 1500 B3l14

HEAD RESTRAINT (U.S.A. Australia and Japan)

727651 (2) Black727653(2) Chestnut727673(2) New Tan727657(2) Shadow Blue

-1625191(2) Black625193(2) Chestnut633053(2) New Tan

. 625197(2) Shadow Blue

NOTE918741(2) Black )918743(2) Chestnut Head Restraint Assembly Trimmed, Leathercloth.922703(2) New Tan Comprising all details on this illustration918747(2) Shadow Blue .Fitted as Special Order to all other markets

722937(2)

IiSPITFIRE MKIV (1973) AND SPITFIRE 1500 10-66 B3115/2

BODY AND FITTINGS-Seat Cushion Assembly (All ~arkets)

*WP0109(4)

t;...615837, /~

917630RH917629L H

RHLH (.:;

911274RH· .~9112731 H

........... 561785 (64)

~

818961818951

727461 RH LBl ack727451 LH I727463 RHLChestnut727453 LH r7297T3 RHl New Tan729703 LH r727467 RH L727457 LHrShadow Blue

Leatherc10th (All Markets918631 RH Black918633 RH Chestnut922593 RH New Tan918637 RH Shadow BlueLeatherc10th (U.S.A. ONLY)918841 RH Black918843 RH Chestnut922803· RH New Tan918847 RH Shadow Blue

NOTE

* U.S.A. OnlyCushion Assemblytrimmed complete(comprising all the abovedetails except Clip 615837)

II SPITFIRE MKIV(1973) AND SPITFIRE 1500 10-67

except U.S.A.)Leatherc10th (All Markets)918621 LH Black918623 LH Chestnut922583 LH New Tan918627 LH Shadow BlueLeathercloth (U.S.A. only)From Commission No. FM10001U918831 LH B1 ack918833 LH Chestnut

. 922793 LH New Tan918837 LH Shadow Blue

B3116/3 .

BODY AND FITTINGS-Seat Slides. Safety Catches and Seat Anjusting Handle (All Markets)

HU0707D(B)

11---624828(4) 1iIWP0023(8)---~

@

IWP004B(8)

YN2908(4)---~~0/{.c:=========.=- ~~~~____ HUOB07 (4)~ ~ /

WP0150(B) ~ .

508194(4) WP0005(4) ( I I 1621458(2) .

II

. / 621776(2)I

~""-., / II I

I I

I I I /717105(2) 624618(2)716144RH716143LH

-r-624870RH-r- 624869LH, 631432RH.631431 RH

NOTEi Hallam, Sleigh and Cheston typei A.W. Chapman type

l~SPITFIRE MKIV (1973) AND SPITFIRE 1500 10-68 B3145

827649(2)

~.627775(2)

~_.

WP8019 (2)/

627646(2)

See Note 6 ..-

BODY AND RTTINGS - Safety Harness - All markets except U.S.A." .-:111

1for U.S.A. details see Illustration 10-7

.,I~ 630663 .i .:.\ ,'.

······;~i~ ,\' ~,'',~' iJ'~ -------, ~ ,! - 10 ,-

J! I ~" / "'j- f?nC i""'J. __ .WL0210(2)!! .~ ~=../.

~-=::.) 629518 (2) _

l~ . 7t'/ ./,/ ~-----. -:r---- ..~./ ;". ---'r-, I II -------..,,_

// i j f/ r I II !

! ./.,,;. 1 I I !/''''1/ r

! \ I f JII x,' I JI( II~, / !,/

/- II': 1/ (II I I' '/

U II,') :II /~i_ il~. / I~ ~I'---.. I"~--'----~.--'-. j~-~~'"~ -----'---., f

719913 ---- "" );1_____..-- f.__ ---..

--"

+630669 (2)t 630669 (4)

\

NOTE719912 Safety Harness Kit 1off Comprising all details on this plate

!Hi30669 (2) Spacer (Soft Top)t 630669 (4) Spacer (Hard Top)

Front Seat Belts for the following countries are local supply and fitment:Switzer1and, Australia, Norway, Finland, Netherlands, Japan, France, Denmark, Sweden.577119 RH.) Monolok and Bracket Assembly577118 LH. comprising items markedtl.

@ Required when Soft Top is fitted" Required when Hard Top only is fitted

SPITFIRE MK IV (1973) 10-69 B3117

BODY AND FITTINGS - Safety Harness -(Seat Sensor Type) Fitted to US.A Type vehicles

627775(2)

631722(2)

632806RH632804 LH

NOTE*Alternatives

SPITFIRE 1500 10-70 63118

MISCELLANEOUS BODY FITTINGS

Part No. Deseri pti on No. perUnit Remarks

BLANKING PLUG DETAILS

Plug, main floor (1" hole) Paint nrainage 4Ho Ies .

Plug, trunk floor (I" hole) Paint Drainage 2Holes

Plug, seat pan (1" hole) Paint Drainage Holes 3Plug, seat pan (l~" hole) Paint Drainage Holes 2Plug, Heelboard Crossmember (~" hole) Paint 2

Drainage HolesPlug, sill panel (l" hole) Paint Drainage· 4

HolesPlug, rear wheel arch , Outer (1" hole) Paint 2

Drainage HolesPlug, heelboard crossmember (I" hole) Paint 2

Drainage HolesPlug, floor hole (13/16" hole) Paint Drainage

HolesScrew, set, skid hole blanking 2Washer, plain, skid hole blanking 2Plug, rubber (5/16") dash shelf panel IGrommet, water valve cable through dash shelf IPlug, blanking, rear bumper holes 2Grommet, number plate cable entry rear valance 1Plug, door (13/16" hole) 4Plug, blanking, bulkhead IPlug, blanking, trunk floor (Required when I

Evaporative Emission Control System isnot fitted)

Setscrew, fitted in bulkhead (l.H.S.) II}Washer, plain, on setscrew (l.H.S.)Plug, rubber (I" hole) Heelboard panel 4Grommet, choke cab Ie R. H.S. IPlug, blanking l.H.S. IGrommet, ai rbox, rev. counter cab Ie Ilabel, approval, door locks, hinges and I

s teeri ngPlug blanking, rear valance Ilabel approval, door locks, hinges and I

steeri ng

600399

600399

600399612301C025672

600398

600399

600399

600421

HU0803WP00086037906191763101861917600421600398600399

PX0703WP0007CD2776961917600398600396158293

600398UKC.0731

ZKe.0191600398609184609185600399600398NKC.0361

Plug, blanking, floorPlug, blanking 'A' post (f' hole)Plug, trunk floor (I" dialPlug, trunk floor 0" dialPlug, rear valance lower (I" hole)Plug, rear wings 0" holelRivet, wheel arches

1In224

Italy only

When Dual Brakingis not fitted

Fitted up to Comm.No. FH.51096U.S.A. onlyFrance. Fitted toall markets fromFH.51097

U.S.A. from Comm.No. FM.1000IU

11 SPITFIRE MK. IV (1973) AND SPITFIRE 1500 10-72 B3119/2

MISCELLANEOUS BODY FITTINGS-Continued

No. perPan No. . Description Unit Remarks

TOUCH-IN-PAINT DETAILS."

GTU.281 EMERALD GREEN A/RGTU.153 WHITE AIRGTU.278 SAPPHIRE BLUE AIRGTU.167 DAMSON AIRGTU.277 PIMENTO AIRGTU.276 SAFFRON AIRGTU.161 SIENNA BROWN 1 Pint tin AIR4

GTU.282 MALLARD AIRGTU.144 BLACK SATIN MATT AIRGTU.301 FRENCH BLUE AIRGTIJ. 302 CARMINE AIRGTU.304 MIMOSA AIRGTU.303 MAGENTA AIR

AEROSOL SPRAYS

GAP. 281 EMERALD GREEN A]RGAP. 153 WHITE AIRGAP. 278 SAPPHIRE BLUE AIRGAP. 167 DAMSON AIRGAP. 277 PIMENTO AIRGAP. 276 SAFFRON AIRGAP. 161 SIENNA BROWN AJRGAP. 282 MALLARD AIRGAP. 144 BLACK SATIN MATT AIRGAP. 301 FRENCH BLUE A/RGAP. 302 CARMINE AIRGAP. 304 MIMOSA AIRGAP. 303 MAGENTA AIR

217614 Towing Attachment Kit - Rear 1

520176 Continental Touring Kit (1300cc Engine only) 1

~ SPITFIRE MK IV (1973) &SPITFIRE 1500 10-73 B3120

OVERDRIVE KIT

611938

217386

o

~.'32115(71.'>132115(2)

WL0207(8)

:.lJ~""sd ~,HN2007(81

106437

~YZ3403(3)

~FJ2444/4131

148897

307862 (For details see Plate V3)

/----""156317/0 RHS1563100 LHS

1563~;/1" RHS156318/1 LHS

518930 Overdrive Kit RHS t Comprising items 011 Plates V1 alld V2518931 Overdrive K~ LHS IDetails on this illustration are fitted up to Commission No. FHSOCOO and FM10000u onlyForfulure see illustrations 10-78, 10-79, 10-00, 10-81, 10-82, 10-83Items marked Aare alternative fitment In sets to items marked ..

SPITFIRE MARK IV(1973) and SPITFIRE 1500 10-74 83121/2

OVERDRIVE - Overdrive Kit Continued

158002"

155030

*SeeBelaw

126792

YZ3504 (2)

J502146~(AlR)127~'58372

• 155985

()~ ..

155983RHS.155984LHS.

*127740

59474

1~72 ~I (051315

106269~-----

NOTE".521031EIl217383"TKC0770<ll217073"520432<1>521066

Items marked EEl are not part of OverdriveTop Cover Extension and Hand Lever Assembly comprising items ~arked '* Kits and must be ordered separately.Propellor Shaft, slrap drive. Allernalivefilmenlto 217073 and TKC0770 tUSA onlyPropellor Shaft, Strap Drive, Alternative Fitrnent to 217383 or 217073 and will be supplied when stocks of 217383 are exhausted.Prupellor Shaft, frictionless. Alternative fitment to 217383 and TKe 0770Gearbox Assembly (Less Top Cover extension, gearbox extension and hand lever)Gearbox Assembly. Reconditioned unit.The above gearbOX assemblies comprise mainshaft Part No. 217386 and all other details in the gearbox sectionDetails on this Plate are fitted up to Commission No. FH6OOClO and FM10000U onlyFor futUre see illustrations 10-78 to 10-83 inclUsive


J TYPE OVERDRIVE KIT-Fitted from Commission No. FH60001 and FM10001U

..

156317/0 RHS156318/1 LHS

'-<?~ ~YZ3404(3)

~ FJ2444/4(3)

313305(for detailssee illustrations10-BO to 10-83)

159639

313085

HU0957(2)--,~~~

11132115(2)"132115 (7)

I

I

I,

I,

I

I

NOTE521169 OVERDRIVE KIT RHS} ... .521170 OVERDRIVE KIT LHS Comprlslng ltems on 111ustrations 10-78 and 10-79

.. Alternative fitment to II

~ SPITFIRE MKIV (1973) AND SPITFIRE 1500 10-78 83125/2

J TYPE OVERDRIVE KIT-CONTINUED (Fitted from Commission No. FH60001 and FM10001U

155030

~137048

~--1~~ 52099'

618511 (2)

V

.See Note·....,."'---1 06269

505031

~ t:. 160331@160194

~~~~T 159653

.127740

~ 100148

"50214~:~~~- L~~~~;&_'_9

, ? \ @127380 ~ , @160335;N t UKC0930 *UKC1l57

59474 ,~

\"-DS1315 ~HB0708(2)

,

158002~.o @Jj(<o'

~@154295158072

83126/310-79

Gearbox Assembly (Less Top Cover Extension, Gearbox Extension and Hand Lever)Gearbox Assembly, reconditioned unitTop Cover Extension and Hand Lever Assembly comprising items marked.Propeller Shaft, strap drive. Alternative fitment to 217073 and TKC0770Propeller Shaft, strap drive. Alternative fitment to 217383 or 217073 andwill be supplied when stocks of 217383 are exhausted

EIl217073 Propeller Shaft, frictionless. Alternative fitment to 217383 and TKC0770Items marked Ell are not part of Overdrive Kits and must be ordered separately.Iterns marked @are fitted up toItems marked T are fitted from

"U.S.A. ONLY * ITALY ONLY

~ SPITFIRE MKIV (1973) AND SPITFIRE 1500

NOTE(l UKC1959Ell UKC1960EIl521031

Ell 217383Ell TKC0770

iI'TYPE OVERDRIVE UNIT - Main Case, Brake Ring,Cam.

@NKC0059 (set of

NKCOO54

@NKCOO58(setof4)

NKC0086

NKC0041

@Not Serviced

@ RTC0553 (set of 6)

500587 (set of 2)

520977(4)

159369

~

NKC 0070(8)--@li

NKC0108 ~NKCOO69(8)

NOfE313305 Overdrive Unit 10ff

{Comprising details on illustrations 10-SO to 10-83 inclusiveNKCOO18 Main Case Service K~ 10ft

(Comprising details@)Details on this illustration 'are fitted from Commission No. FH6OOO1 andFM1OOO1U


t1' Type OVERDRIVE UNIT - Annulus, Sunwheel. Planet Carrier.

NKCOO4O

NKCOIX.-

NKC0016

513208

NKCOO20

NKcoon

NKCOO84

NKCOO22

NOTEDetails on this illustration are fitted from Commission No FH6OOO1 and FM100Q1U and future.

SPITRRE MK IV (1973) and SPITRRE 1500 10-81 63128/2

U' TYPE OVERDRIVE UNIT-Rear Case,Speedo Gears,Flange.

160286NKC0082

NKCOO39

513897

NKC0105

NKCO\(6l LNK~C0088(:KC0089(2)

'(, NKCOO78

Q.

NKC0045

NKC0087

SP74G

NOTEDetails on this illustration are fitted from Commission No. FH6OClO1 and FM10001

SPIJARE MK IV (1973) AND SPllFJRE1500 10-82 8312912

tI' Type OVERDRIVE UNIT-Relief Valve, Pump details.

NKC 0100

NKCOQ25

----=:::c::.'NKC 0015

NKCOO91

o

. NOTEDetails on ttus illustration are fitted from Commission No. FH6OOO1 and FM1DOO1U


OIL COOLER

HU0705(2)

211794

I

140473RH

WPOOOB TN320712)

140600

140472LH

NOTE514082 Engine Oil Cooler Kit 10ft (Comprising all above detailsl

513971 130148

130141

--140601

SPITFIRE MK IV (1973) and SPITFIRE 1500 10,-84 . B3131

PART NUMBER

3230732307359(,0362343641137948424254375256177563055693456935571105745857(1)25795J582585826158923591915938059426594745949259813M070601426191770391

100148100433100498100500100501l010221010891013021C134310196210268910269010298710442010443310H38104445104449104549H)4552104554104581104582104737104738104740104742

OESCR IPT ION

WASHER FELT ON DIPSTICKPIN ANCHORING TENSIONER SPRINGCHAINWHEEL CAMSHAFTPIECE FILLER-SEALING BLOCK ATTACHMENTPLATE LOCKING CHAINWHEEL TO CAMSHAFTSHIM UNDER SPRINGTENSIONER SPRINGPLATE ANCHORCONNECTOR DOUBLE SNAPSCREW LOCKING SPEEDO DRIVEN GEARBOX EXTENSIONNIPPLE GREASENIPPLE GREASE INNER HUBLOCKNUT FITTED TO ROCKERSRAND COVER ASSEMBLYADAPTOR CYLINDER HEADSPRING RETURNCLAMP MANIFOLD TO CYLINDER HEADGAITERGUIDE VALVECLIP FRONT PIPE TO CHASSISCLIP CLUTCH PIPESPANNER ePEN-ENDED 1.50 "\IF .56 AIFINUT INHIBITOR SWITCH TO BRACKETBULB INSTRUMENT ILLUMINATION& WARNING lIGHTSSCREW SIT BATTERY LEADS TO BATTERYBUSH BEARING CAP .NUT UNION PIPE TO TANKGROMMET FITTED IN SUPPORT BRACKETSET SUNDRY PARTSCLIP PETROL PIPE SUPP FIr-TO AIR CLEANER BOLTSTUD BEARING HOUSING ATTACHMENTNUT MAN IFOlD TO CVlINOER HEAOSETSCREW CHAINWHEEL TO CAM~HAFT

SCREW SEALING BLOCK ATTACHMENTSCREW SET OIL GALLERY SIDES ROCKER OIL FEEDSPANNER SPARKING PLUGNUT PIPE TO ADAPTORADAPTOR WATER PUMPSTUDCOVER HUB ENDWASHER D HUBS TO STUB AXLESBUSH RUBBER DAMPER EYEIUSE WITH GIRUNG&WOCDHEBUSH IN REVERSE GEARBEARING BALL FITTED ON SHAFTWASHER OUTER FITTED ON CONSTANT PINION SHAFTSPRING IN SYNCHRO SLEEVEPLUG SELECTOR SHAFT HOLESSHIM STARTER MOTORBALL JOINT ASSY UPPER WISHBONEIFIT GREASE NIPBOLT BEARING CAP ATTACHMENTKEY AXLE SHAFT REAR HUB TO AXLE SHAfTCATCHER CIlPAWL fITTED IN lEVERPIN FITTED IN LEVERSPRING PAWL RELEASESEGMENT RATCHET

32307

09-0409-0809-0809-0409-0809-4009-0809-0810-2109-3709-4709-51(;9-0610-071.0-4309-0609-1.409-4709-0609-.7409-7109-711.0-1910-1810-2009-5209-7610-11.10-0709-7109-2509'-1.409-0809-0409-0409-8309-1409-lft;09-0409-4709-4709-5509-4140-0<;:09-41.09-4009-39I. 0-0709-4709-5209-5109-5 I.09-6809-6809-6809-68

104742

PART NUMBER

10474310414910475010417310417510485910486010486110493910fi963104964105114105115105118105120105121105123105124105125105131105143105290105321105322105438105605105690105745105B69106030106084106088106:>901061')92106094106095106155106156106157106158106254106268106'269106270106365106386106437106448106477106478106481106489106663107072'107099107246

DESCRIPT ION

PIN FULCRUM H/8RAKE LEVER&RATCH TO MOUNT BRKTFORK-END REAR CABLEPIN CABLE ATTACHMENTHOUSING CIL SEALSEAL OIL BALL JOINT ASSEMBLYSCREW LOCATING DRILLED PEDESTAL TO SHAFTGEAR DRIVING DISTRIBUTOR AND OIL PUMPSHAFT OIL PUMP DRIVEWASHER JCINT PEDESTAL TO CYLINDER BLOCKI.006PLUG \OGRE OIL PUMP BODYBODY ASSEMBLYPLATE LOCATING CAMSHAFT IN CYLINOER BLOCKKEY LOCATING CHAINWHEEL&PULLEY ON CAMSHAFTCOLLAR SPRING VALVE LOWERSPR ING ReCKERSTUD CYLINDER HEAD ATTACHMENTSTUD ROCKER COVERSTUD MAN IFOLD ATTACHMENT OUTeRSTUD MANIFOLD ATTACHMENT INNERCHAIN TIMINGBUSH CONSTANT PINION PILOTPLATE CLAMP FLE~ STRIP TO 80DY&SILENCER/TAILWASHER JCINT TWEEN OILSEAL HOUSING&CYL BLOCKSPRING ROCKER NO 1 AND 4 PEDESTALSNUT STEERING WHEELBUSH PEDAL TO SHAFTSPRING S~OE RETURN CYLINDER HEADSTUD CAR e TO MANIFOLDSPRING SHOE RETURN ADJUSTER ENDCLIP HANGBRAKE CABLESPRING BETWEEN PISTON AND BODYRETAINER SPRINGWASHER SPRING VALVE HEADCIRCLIP PUSH ROO RETAININGLID RESERVOIRGASKET ON RESERVOIRPLUNGER CVLINDERSPR I NG PLUNGE RSTEM VAL \iESEAL VALVEREVERSE OPERATING LEVER ASSEMBLYFORK SELECTOR 3RD/TOPWASHER JOINT TOP COVERWASHER T~RUST REAR OF COUNTERSHAFTTHROWER OIL FITTED ON CONSTANT PINION SHAFTSPRING SYNCHRO SLEEVEWASHER (PAPER} EXTENSION TO GEARBOXFULCRUM REVERSE OPERATING LEVERSCREw LOCATING SPINDLEPIN INTERLOCK fITTED IN TOP COVERPLUNG SElECT SHAFT IS.T I2ND/3RO/TOP FIT TOP COSPRING PLUNGER SELECTOR SHAFTCONE SPLITGASKET HOSEPLUG INTERLOCK HOLEPLUG RETAINING PISTON & SPRING IN BLOCK

09-6$09-6809-6809-5109-5909-0609-0809-0809-0609-1009-1009-0809-0709-0609-0609-0409-0609~06

09-0609-0809-0709-800"1-0509-0609-5809-6309-7009-2709-7009-6809-3409-6509-6509-6509-6509-65OQ-6509-6509-6509-6509-4109-3909-3909-4109-4109-4010-7609-4109-4109-3909-3909-3909-0609-7109-3909-04

104743 101246

PART NUMBER ·,OESCR IPT ION

10740110802110830110830210832510833410834110834910835010835110835510865110815110886010B94310891610897710902310902410918210919010949511037611046111061911)148lID 960111054111163111422lU4Z31118701118141119191123941124291125091125161126261126351126541127441129011130711131181113150113229113868114006114034llH18114438114149114114115706115784CON

DOWEL HOLLOWSHAFT SELECTOR 3RO/TOPSPRING PISTON (REDISCREw LIC TO FLOAT CHAMBERNUT LOST MOTION LEVERS TO CONNECTING ROOPIN HINGESPRING PISTON LIFT PINSCREW SECURING aISC ON SPINDLEBOLT LOST MOTION LEVERS TO THROTTLE CONN RODWASHER SPRING LID TO FLOAT CHAMBERSPRING LOCKING SCREwBRUSH HORN PUSH CONNECTIONSEAL OILEXTENSION TUBINGCLAMP HEATER CABLEBOLT PLAlE AND ~USHES TO ADAPTORBUSH RUBBER ADAPTOR PLATEROCKER NC 1ROCKE R NO 2ROD PUSHSEAL PLUNGERPIN ADJUSTMENT ROCKER SHAFTPIN LOCATING CROSS PIN IN DIFFERENTIAL HOUSINSTRIP CONDUCTOR ON BOLTHASHER DAMPER TOP CAPNUT CYLINDER TO BLOCKPLATE FLEXIBLE JOINTTAPPET BETHEEN WEDGE AND SHOESPACER VALVEWASHER THRUST FITTEo TWEEN .2ND&3RO SPEED GEARBUSH 2ND/3RD SPEED GEARCOLLAR VALVE SPRING UPPERPUSH ROOSEAL TAPER CYLINDER PLUNGERCIRCLIP RETAINING GEAR ON MAINSHAFTSUO WHEElPLUG THRUST BALL THROWOUT SLEEVE TO lEVERPIN PUSH ROD TO LEVERCASKET OVERDRIVE UNIT TO GEARBOX ADAPTORNUT SLOTTED SECURING FLANGE TO PINIONRING SNAP FITTED ON SHAFTTUBING CONTAINER TO PLUNGER L H SSTUD GEARBOX AND REAR ENGINE PLATE TO BLOCKSPINDLE REVERSE IDLER GEARNUT WHEEL (COVER FIXING)BOLT FRICTION DISC TO HUBHASHER THRUST FRONT OF CCUNTERSHAFTFORK SELECTOR 1ST/2NDBUTTON THRUSTWASHER STEEL COUPLING TO OPERATING SHAFTCROMMEl PETROL rIPE fITTED IN CLIPSPRING PEDAL RETURNWASHER JCINT HYPOID HOUSING TO AXLE HOUSINGPLUG OIL DRAINaOOT RUBBER STARTER SOLENOIDNECTOR PIPE

107401

09-0709-3909-3209-3209-3109-3209-32

.09-3209-'-3109-3209-3210-0909-3110-0910-4209-5B09-5809-0609-0609-3809-6509-0609-5209-5809-3209-0609-5809-7()09-6509-'-4009-4009-()609-0609-6509-4009-5109-3809-3810-7409-'209-4010~1l

09-2009-4110-4509-7009-4109-3909-5509-4209-3109-6309-5209-05lQ-2009-16

115784CON

115990

09-5209-6609-0409 1209-3709-550"1-5209-5109-5209-4209-4209-4209-5509-0409-5209-5209-3109-3109-3709-1+809-4209-4209-4209-1+209-4109-0709-0709-4809-4709-4209-6309-6509-0409-0709-4109-4109-70

·09-3409-7009-7009-4209-4209-3109-5909-5909-5909-5909-5909-5909-5909-590"1-5909-0409-0409-0809-68

121699

PART NUMBER

11599011&201116516117400117510117575117518117853117952118040118053118054118599118632118826118977119090119~99

119100119142119251119252119262119263l1q27211938911'139011945Cl11'145111'157311957511958311975B11981311989111989312012412012812013412m3512030512030712033112069412094112094612094812094Q120953120955120957120Q59121217121398121530121699

OEseR IP TION-

WASHER PLAIN BETWEEN PINION fLANGE ANONUTGASKET ADAPTOR TO BODYPLUG CORE BELOW Oil fILTER FACESLEEVE STRAIGHT VACUUM PIPESEAL OIL EXTENSION ENDBUSH RUB8ERBUSH MaUllTI NGBEARING NEEDLE ROLLERSEAL OILLEVER GEAR IINTERNALISEAL allNUTPIN FULCRUM REAR DAMPER UPPER ATTACHMENTPLUG DRY SEAL OIL GALLERY ENOSPLUG COREWASHER LOCK CROWN WHEEL TO DIffERENTIAL CASINBEARING END THRUST SPEEDe DRIVE SHAFTa RINGGEAR SPEEDO ORIVEN ASSEMBLYBOLT TRUNNION TO WI SHBONESPRING CAP RETAINERSPRING REVERSE BAUlKBUSH OPEAATING SHAfTCIRCLIP RETAINING SPRING ON LEVERTOP WISHBONE ARM AND 8USH ASSEMBLYWHEEL CHAIN CRANKSHAf-TDEFLECTOR OILBUSH RUBBER LOWERBUSH RUBBERWASHER DISHED OUTERSHAFT PEDALBRACKET SUPPORT CLUTCH MASTER CYLINDERSTUD

. BUSH SMALL ENDRING RETAINING NEEDLE ROLLERSROLLERS NEEDLEPIN SHOE HOLD DOWNCAP OUSTCOVER DUSTRETAINER DUST COVERWASHER JCINT TOP COVER EXTEN & HAND LEVER ASSPLATE RE~ERSE BAULKPIPE flEXIBLE fRONT TO REAR CARB PETROL PIPEANGLE DRIVE SPEEODSHIMPLUNGERBELLOWS PASSENGERS SIDESHIM .004SPR I MGSOCKET BALLWASHER TABSHIM .G02STUD CYL HEAD & REAR LI,FTING EYE ATTACHMENTOIL PRESSURE INDICATOR SWITCH,PEDESTAL DISTRIBUTORCOMPENSATING SECTOR

PART NUMBER OESCR IPT ION REF. NO.

09-6809-6809-6809-6B09-68

LEVER 09-6809-7109-040.9-5109-5109-4809-5109-4709-'t809-6509-4809-380'1-3709-3909-5809-4409-5809-5809-8309-4509-7709-7009-7009-45

'_ 09-48, 09-53

09-4209-4909-6309-0810-2109-49·09-4909-8309-4809-5809-5809-4209-4209-5910-0910-7509-4209-4209-0709-5909-5909-5909-5"109-5909-59

SEAL OUST RUBBERBEAR I NGWASHER TAB RELAY LEVER TQ BODYPIN SHOULDERED RELAY LEVER TO aOoYSEAL FELT RELAY LEVERHANDBRAKE CABLE ASSYIHANDBRAKE TO RELAYCONNECTOR DOUBLE END UNIONTUBE DIPSTICKWASHER TAB OllSEAL HOUS&8ACK PLATE ATTACHMENTBOLT OiL SEAL HOUSING&BACK PLATE ATTACHSHIM WISHBONE FULCRUM BRACKETS FRAMEPLUG SCREWED INNER HUBSEAL OIL TRUNNION TO VERTI~AL LINKPLATE ASSEMBLY ~PRING RETAINING UPPERROO PUSH ASSEMBL YSEAL DIRT LOWER TRUNNiONCOVER FRONT ENDWASHER PAPER CLUTCH TO GEARBOX CASESCREW SET (WEDGLOKI SELECTOR TO SHAFTSCLAMP STEERING COLUMNREAR ENGINE MOUNTINGCAP END STEER H:G COLUMN COWLWASHER BEARINGSPANNER OPEN-ENDED 11/2 A/f-7/16. A/flCUP WIR INGCONNECTOR FLEXIBLEPISTONOPERATING LEVER ASSEMBLY WHEEL CYLINDERPLATE STlFFENERCAP SPRING PLATESCREW B.E'ARING RETAINING CAP TO HOUSINGBOLT OPERATING SHAFT TO HAND LEVERSTUD LINK ASSEMBLY TO ANTI-ROLL BARCOVER OUST CLUTCH PEDALWASHER JOINT PEDESTAL TO CYL BLOCK 1.020CLIP HEADLAMP CABLES TO BONNET HINGELINK ASSEMBLY R HLINK ASSEMBLY L HFEELER GAUGE ASSEMBLYSTRUT LOhER WISHBONESCREW LOCATING CLAMP TO STEERING COLUMNPLATE LOCATING CLAMP TO STEERING COLUMNCAP TOP COVER EXTENSIONDOWEL CAP TO TOP COVER EXTENSIONSPR INGRELAY OVERDRIVESWITCH INHIBITORSHAFT GEAR LEVERCOUPLING GEAR LEVER SHAFTDOWEL FlYWHEEL TO CRANKSHAFT ATTACHMENTBUSH PINION LOWERBUSH PINION UPPERWASHER THRUST UPPERWASHER THRUST LOwERPLUG ENDBUSH RACK TUBE

12115512175712175812175912176012176612178212183112186D121862122022122115122126122131122296122534122566122 56912265312266912268912271812211912274512274712279612305912313512320312323112380-3125054125014125217125" 5212546912548112548212550512573312578112578212&607126154126165126792127380127740127741:127883121997127998127999128000128001128002

121755 12B002

. REF. NO.PART NUMBER

128004128,')081281)20128021128022128023128024128262128356128313128469128512128978129071129119129120129242129358129383129410129412129650129833129961129963130031130032130141130142130148130415130757130758131008131155131169131211131289131312131368131465131492131535131567131570131786131796131806131807131843132023132053132055132068132098132\04

DESCRIPTION

BELLOWS DRIVERS SIDEPINCOVER ENeo R. INGLOCKNUT BALL JOINT ATTACHMENTPIN BALLMOUSING BALL

, SLEEVE RUBBER SUCTION pIPESHIM FRONT SUSPEN MOUNTING 8RKS TO CHASSIS FRWASHER DISHED INNERFLING"ERBEARING BALLSEAL OILDRAIN PLUG CYLINDER 8LOCKSLEEVE PINCH IN HAND LEVERSHAFT OPERATINGPLUG GREASE VERTICAL LINKBUSH DISENGAGING LEVERSTUO CARBURETTOR TO MANIFOLDPIN FULCRUM DISENGAGING LEVERRING TOLERANCE DISENGAGlNG LEVERPLATE TAPP FRONT SUSPEN MOUNT BRK TO CHASSISCOMBINATION TOOLINNER BALL JOINT ASSYSLEEVE ADAPTORSHIM .002SHIM .010SCREW ADAPTOR ATTACHMENTTAB WASHER ADAPTOR ATTACHMENTADAPTOR OIL FILTERGASKET INTERNAL ELEMENT TO AIR BOXLOWER WISHBONE FULCRUM BRACKET FRONTLOWER WISHBONE FULCRUM BRACKET REARSTUD REAR ROAD SPRINGGROMMET BULKHEADSCREw SIT 8ATTERY LEADS TO BATTERYSLEEVE RUBBERFURRULEGRIP HANCBRAKE LEVERSPRING ACCELERATOR CABLERIMWASHER SEALINGSPRING pISTONREAR HUB AND STUD ASSYPACKING STARTER MOTORBUSH OIL PUMP DRIVE SHAFTRUBBER MCUNTINGREAR AXLE LOwERSPRING PULL-OFF HANDBRAKE REAR CABLEPLATE SPRING ANCHORWASHER THRUST FITTEA TwEEN 2NV&3RO SPEEDGEARSBOL T SHAFT JOINT TO INNER AXLE SHAFTCAP SCREWEDSHIM .010NUT WING SECURING BATTERYo RING (USE WITH A C DELCO FILTER G F E 1191BRACKET SUPPORT INNER SUSPENSION R H

09-5909-5909-5909-5909-5909-5909-5909-1109-4509-4209-5109-5209-5109-0409-4209-4209-4709-3809-1409-3809-3809-4509-8309-5909-5909-5909-5910-8410-8410-8409-3009-4809-4809-5109-7810-2009-1109-6009-6809-6110-1609-6009-0409-5110-0709-0409-5109-6809-6809-4009-Sl09-5909-5910-2009-1009-45

128004 132104

PART NUMBER

132105132107132115132242132328132365132366132368132435132439132495132 5/>51325861325881325891326681327541327631327641321319132856132872133070133103133122133319133568133581133582133875134065134il7013407213407313407413407513407613417413't30113If 3991344001345751346031346881346891347471347481347511 J4. 75413481413ft 891134933136604136868136869136890

DESCRIPTION

BRACKET SUPPORT INNER SUSPENSION L HPISTON OIL RELIEf VALVESTUD ADAPTOR TO GEARBOX CASEINSERT VALVE SEAT EXHAUST VALVEFLf(NGE YCKEBRACKET HOSE MOUNTING R HBRACKET HOSE MOUNTING l HSPANNER SPARKING PLUG SPECIALBRACKET REAR REARAXlE MOUNTINGBOLT CALIPER ASSEMBLY TO MOUNTING BRACKETSTUD ROCKER PEDESTALTAP DRAINLEVER ASSEMBLY HAND BRAKEROD ASSE~BLY PAWL RELEASEHANDBRAKE ASSEMBLYSEAL FELTBRK ASSY REARBODY MOUNT RHIFITTED REAR OAMPERREAR VERTICAL LINK ASSEMBLY R HREAR VERTICAL LINK ASSEMBLY L H8RK ASSY REARBODY MOUNT LHIFITTED REAR DAMPERBOLT MOUNTING PLATE TO HYPOIO HOUSINGBOLT DOwEL GEARBOX UNIT REAR ENG PlATE&CYL BLSHIM PIVOT BRACKET TO BOOY FLOOR ATTACHMENTPLUG GREASEBRK T EXHAUS T PIPE MOUNT WELD TO INHRMED XMEMBRACK ET CLAMPRUBBER MCUNTING REAR AXLE UPPERCAP FILLER RESERVOIRSEAL AOAPTOR TO RESERVOIRPLATE REINFIRCE "RACK&PINION BODY TO FRAMEBEARING ROLLER PINION HEADBEARING ROLLER PINION NOSEPIN CROSS OIFFERENTIALGEAR DIFFERENTIAL 16 TEETHPINION DIFFERENTIAL 10 TEETHWASHER THRUST FOR DIFFERENTIAL GEARWASHER THRUST SPHERIC PINIONGEARI.030 1.032STARTER SOLENOID SWITCHEARTH BOND STEERING RACK TO CHASSIS R H SOUTRIGGER ASSEMBLY INTERMEOIATE R HOUTRIGGER ASSEMBLY INTER~EDIATE L HRING LOCKING GAUGe UNITWASHER DISTANCE L H SIDE Of PLATEPINION L H SPINION R H SBUSH FRONT CHROME PLATEDBUSH RUBBER REARSEAL RUBBER WHEEL BOXWASHER GAUGE UNIT SEALINGLEVER HMOCLAMP HOUSING ASSYDIPSTICK ASSEMBLYBALL JOINT ASSEMBLY UPPER WISHBONEPIECE DISTANCE REAR AXLE MOUNTINGBOLT REAR AXLE TO FRAMEBRACKET GEARBOX MOUNTING ASSEMBLY

132105

REF.NO.

09-"'509-0410-7409-2209-5109-7109-7109-8309-4509-7009-0609-8209-6809-6809-6809-4709-4509-5509-5509-4509-5209-3809-5509-5909-450'9-4509-5109-6609-6609-5809-5209-5209-5209-5209-520:9-5209-5210-0710-2109-4509-4509-7609-5109-5909-5910-1010--1010-1009-7609-4210-0509-0409-4709-4509-5109-44

136890

P~RT NUMBER

13t> 90813693913(,99013704!l1373081376321 '376B713774313774711371'47213777513781113783413784213784513809213A176138316113831601384401384411384421385261385291'38531)138558138559138608138685138701138702·138791138807138369

.13889213892613938613953013953113953213956313982714047214041314054')14060014060114079014079114:>7921401'l3140797140798140892140893140894

OESCR IPT ION

CONNECTICN THREEWAYCONNECTICN FOUR WAYPLUNGER SELECT SHAFT REVERSE FITTED TOP COVERCLIP BR~KE PIPE FRONT SUSPEN MOUNTING BKT RHRING SPRING SECURING CAMBOTTLE RADIATOR OVERFLOwPIECE DISTANCE REVERSE IDLER GEARCAP OVERfLOW BOTTLERELAY HORN LUCAS HORNSRELAY HORN CLEAR HOOTERS HORNSWASHER BETWEEN CENTRE BEARING & 1ST GEARPLUG ROCKER SHAfT ENDCOLLAR SPLIT 1ST GEARBRACKET ASSEMBLY PEDAL MOUNTINGCLAMP MANIFOLD TO CYLINDER HEADBEARING SPEEDO ASSYCAP OIL FILLER ASSYCABLE INNER REV COUNTER L H SCABLE OUTER REV COUNTER L H SWASHER THRUST SPHERICAL PINION GEAR 1.027 IWASHER T~RUST SPHERICAL PINION GEAR 1.035 )wASHER THRUST SPHERICAL PINION GEAR 1.039 )BOLT FLY~HEEL TO CRANKSHAFT ATTACHMENTBOLT CONNECTING ROOADAPTOR HOSE FITTED IN wATER PUMP 80DYBOLT TIE ROD LEVER&DUST COVE TO VERTICAL LINKSHI ELD "'ATERGROMMET FOR CLIP R H 5BUSH SPHERICALGASKET BETWEEN BEARING HOUSING&PUMP BOOYGASKET BETWEEN PUMP AND CYLINDER HEADGASKET PETROL PUMPCLrp SILENCER&TAIL PIPE ASSY TO EXHAUST PIPECLI P GA ITERCLIP SUCTION PIPE TO PETROL PIPEVALVE OPERATINGMOUNTING RUBBER RACK ANC PINION BODYCAP BEARING RETAININGINNER AXLE SHAFT ASSEMBLYCIRCLIPSLEEVE BAll THROW-OUTBRKT MOUNTING EXHAUST PIPE TO AXLE MOUNT FLATBRACKET ~OUNTING L HBRACKET~OUNTING R HCLIP TRAFFICATOR CANCELLINGHOSE ENGINE TO OIL COOLERHOSE OIL COOLER TO ENGINESHIM ADJUSTING BEARING PINION NOSE (.030 )SHIM ADJUSTING BEARING PINION NOSE 1.010 ISHIM ADJUSTING BEARING PINION NOSE 1.005 ISHIM ADJUSTING BEARING PINION NOSE 1.003 IRING COMPRESSION CHROME PLATEDRrNG COMPRESSION TAPERED PERIPHERYBEAR I NGPIECE DI STANCESHIELD WATER INNER

09-H09-7109-3909-7110-7609-B209-4109-8210-0910-0909-4009-0609-4009-6309-1409-3709-0610-1810-1809-5209-5209-5209-0709-0709-1409-4709-4709-7109-4209-0909-0909-1509-Bl09-5909-3110-7609-5809-5209-5209-5209-3809-8010-8410-8409-58

·10-6410-8409-5209-5209-5209-5209-0709-0709-4809-4809-48

136908 140894

PART NUMBER

14()8951409191409201411851412181412211412421414431414441414-75141606141675141761

. 142002142087142139142140142281142333142649142774142795143213143214143215143323143456143552143747143802143921143922143952144070144101144102144103144104144117144195144255144259144297144370 I144370014"580144595144648144686144681144688144716144182144961144962144965

OESCR IPT ION

SH1ELO WATER OUTERBOTTOM TRUNNION ASSEMBLV R HBOTTOM TRUNNION ASSEMBLV L HSEAL OJ RT.BEARING ~YLON INNER BU8PIECE 01 STANCESEAL OIL ON PINIONSHIELD OUTERSHIELD H,NERPIPE OVERFLOWBRACKET ASSY OVERFLOW BOTTLE SUPPORTFLYWHEEL ASSEMBLYBATTERY tCANADA ONLYIREAR NUMBER PLATE LAMPANGLE BATTERY RETAININGADAPTOR FLEXIBLE JOINTFLEXIBLE JOINT ASSEMBLYCLIP EXHAUST PIPE ATTACHWASHER PLAIN REAR HUB TO AXLELIFTING EYE BRACKET REARCYLINDER LINERLOCKNUTo RING PROP SHAFTBOLT PROP SHAFT STRAPSSTRAP FOR PROP SHAFTHOSE T PIECE TO CARBURETTORSEAL OIL CRANKSHAfTVALVE TAPPETLINK THRCTTLE SPR1NGNUT ALTERNATOR MTGBALL JOINT ASSEMBLY TIE ROD ENDGAllER ASSEMBLYWASHER PACK1NG PLUNGERSTUD MANIFOLD ATTACHMENT INNERCIRCLIP HALF SHAFT JOINTCIRCLIP HALF SHAFT JOINTCIRCLIP HALF SHAFT JOINTCIRCLIP HALF SHAFT JOINTCLIP EDGE MAIN HARN TO FRONT SUSPEN MOUNT BKTWASHER THRUST (OBTAINABLE .005 OVERSIZEILOCTITE RETAIN1NG COMPLOCTITE PRIMER T FILLER INSERTBoOY WATER PUMPCABLE INNER REV COUNTER R H SCABLE OUTER REV COUNTER R H SREVERSE IDLER GEAR ASSEMBLYCOUNTER SHAFTPLUG CORE BUCKET TYPE IN REAR FACE OF HEADPLUG CORE BUCKET TYPE IN REAR FACE OF HEADPLUG CORE BUCKET TYPE FRONT FACE OF BLOCKPLUG CORE BUCK TYPE FRONTFACE&RH SIDE OF BLOCCLUTCH SLAVE CYl ASSEMBLYBEAR I NG NEEDLE ROLL ERBOLT SHAFT TO MAINSHAFT OR OVERDRIVE UNITROCKER SHAFTVALVE EXHAUST

14089')

09-4809-4809-4809-5109-5109-5109-5209-5109-5109-8209-82

.. 09-2310-2010-1610-2009-5809-5809-8009-5109-0609-0409-5909..,.5709-5109-5709-1309-0509-0609-6009-1609-5909-5909-5909-0609-5109-5109-5109-5110-2109-07

·09-5209-5209-0909-0910-1809-41C9-4109-0609-0409-0409-0409-3409-4109-5709-0609-22

144965

PART NUMBER

14497314497414497514510814519714527514527614532814589014589114591814591914592014592114592214592314592414592514592614592714592914592914593014593114593214593314610214617614624014630314632614641314642214642314645414647914648514648714b48814672Bl'tb91414698414!>987147223147249147251147252141277

·14135414139414746714747114H83141520147630141632

OEseR lPT lON

PEDESTAL ROCKER NO 1PEDESTAL ROCKER INTERMEDIATEPEDESTAL ROCKER NO 4 DRILLEDPLUG NYLON FITTED RACK AND PINION BODYSPRING THROTTLE RETURNSHIM CHAINWHEEL TO CRANKSHAFT ~.004 ISHIM CHAINWHEEL TO CRANKSHAFT (.006 IVALVE INLETCLEAT FLASHER CA8LECLEAT FJRTREE ACCELERATOR CA8LE TO HEAT HOSESHIM ADJUSTING BEARING PINION HEAD 1.075 ISHIM ADJUSTING BEARING PINION HEAO 1.0765 ISHIM ADJUSTING BEARING PINION HEAD 1.078 ISHIM ADJUSTING BEARING PINION HEAD 1.0795 ISHIM ADJUSTING BEARING PINION HEAD I.C81 ISHIM ADJUSTING BEARING PINION HEAD 1.0825 ISHIM ADJUSTING BEARING PINION HEAD (.084 1SHIM ADJUSTING BEARING PINION HEAD (.0855 ISHIM ADJUSTING BEARING PINION HEAD 1.087 1SHIM ADJLSTING BEARING PINION HEAD (.0885 ISHIM ADJUSTING BEARING PINION HEAD (.090 1SHIM ADJUSTING BEARING PINION HEAD 1.0915 ISHIM ADJUSTING· BEARING PINION HEAD 1.093 ISHIM ADJUSTING BEARING PINION HEAD 1.0945 ISHIM ADJUSTING BEARING PINION HEAD (.096 ISPACER BETWEEN BEARINGSCOUPLING flANGEBOLT CLUTCH ATTACHSHAFT SELECTOR IST/2NOWASHE R PLA I NDRAIN TAP CYLINDER BLOCKBRACKET SUPPORT BRAKE MASTER CYLINDERBRAKE MASTER CYLINDER ASSEMBLYBRAKE MASTER CYLINDER ASSY PLASTIC RESERVCIRCONNECTI~G ROO ASSEMBLY (LESS BEARING)HUB ASSE~BLY FRONTPIN GUDGEONINSERT VALVE SEATINSERT VALVE SEAT INLET VALVEBALL JOINT ASSY TIE ROD END~FITTED GREASE NIPWASHER PLAIN SPACE ADJACENT INTERMED ROCK PEDNUTBElfLPLATE RETAIN ASSY SAfETY HARNESSISIDE MEMBERlWASHER THRUST SPHERICAL PINION GEAR (.029WASHER THRUST SPHERiCAL PINION GEAR (.037 IWASHER THRUST SPHERICAL PINION GEAR I.D43 IFLASHER INDICATOR SWITCH R H SBUSH lRD SPEED GEARACTUATOR REVERSE GEARLEAD COIL TO DISTRIBUTOR IH TIREVERSE LIGHT SWITCHSPACER ALTERNATORWASHER THRUST SPHERICAL PINION GEAR 1.033 )PLATE SUPPORT OVERDRIVEMOUNTING REAR ENGINE

1't4913

REF. NO.

G9-0609-0609-0609-5909-3109-0709-0709-0610-0909-61(;9-5209-5209-5209-5209-5209-5209-5209-5209-5209-5209-5209-5209-5209-5209-5209-5210-1709-3409-39G9-4209-0409-6609-6609-6609-0109-4709-0709-0609-()609-5909-0609-6011)-1809-4509-5209-5209-5210-0909-4009-3910-0410-1909-1609-5210-1410-14

147632

,LEAD REVERSE LIGHT SWITC~

SRKT fRONT EXHAUST PIPE TO GEARBOX EXTENSIONBRACKET ALTERNATORADJUSTER CABL EfAN ALTERNATORGASKET AIR CLEANER TO CARBURETTORSEGMENT RATCHETSHIM AOJUSTING REARING PINION HEAD 1.077 )SHIM AOJlSTING BEARING PINION HEAD (.079 )SHIM ADJUSTING BEARING PINION HEAD (.080 )SHIM ADJlSTING BEARING PINION HEAD I.OB2 )SHIM ADJUSTING BEARING PINION HEAD (.083 ISHIM ADJUSTING BEARING PINION HEAD (.085 )SHIM ADJUSTING BEARING PINION HEAD (.086 )TANOEM BRAKE MASTER CYLINDER SUPPORT BRACKETPLUG CORE BUCKET TYPE REAR OF CAMSHAFTNACELLE ~ASTER LIGHT SWITCHGASKET ELEMENT SEALINGSPRING PLUNGER FITTED IN TOP COVERCLIP FLASHER SOCKET ATTACHMENTLIGHTING SWITCH HEAOLAMP'OIP AND FLASH L H SWASHER Tt;RUST SPHER ICAL PINION GEAR (.041 ICLIP BRA~E AND FUEL PIPEHAZARD wARNING LIGHT L ~ S ONLYVOLTAGE STABILISERPLATFORM OVERDRIVE MOUNTINGBEARING elG ENDBEARING ~AIN

TUBE PVC WATER VALVE CABLE L H S ONLYGEARBOX CASEPLATE SA SESPACERPAD REAR SPRING BETWEEN PIV BRKT&ROAO SPRINGDISC THROTTLE AND AIR VALVE ASSEMBLYGASKET eeoyBRKT ACCELERATOR CONTROLlfIT TO ROCKER CDV STHOSE CAReURETTOR TO CANISTERCONNECTOR FLEXIBLE PETROL PIPEEXTENSIO~ DUST COVERRueBER MOUNTING AXLE CASINGHOSE FEEC WATERPUMP BCDY TO INLET MANifOLD FRHOSE RETURN PIPE TO INLET MANIfOLD (REARISPECIAL CIL REAR AXLE TOPPING UP 1 PINT TINWASHER T~RUST fiTTED TWEEN ZND&3RD SPEED GEARLEAD EXTENSION DUAL BRAKE SWITCH L H SSWITCH WARNING LIGHT PRESSURE OIFF VALVEGASKET FRONT SEALING BLOCKCUP SYNChRO 1ST & 2NO 3RO AND TOP GEARSMASTER LIGHT SWITCH (OFF SIDE-HEAD)LEAD PLUG H T NO 1LEAD PLUG H T NO 2LEAD PLUG H T NOS 3 AND ..CONNECTORTEMPERATURE TRANSMITTER (BLACK)PAD FIXING RUBBER WIPER HOTOR MOUNTINGSTRAP & SLEEVE ASSY WIPER MOTOR MOUNTING

PART NUMBER

14777714779114789914793014799014800614808314809914810014810114810214810314810414810514815614835314843714859914860414862114864814880514882014883014687614IH\97149061149082149137149140149189149190149191149265149266149348149607149608149623149648149699149700

·14'1876149963149967'14997115002215Cl328IS:n80150547150548150549150698150843150844150846

OESCR IPT ION

147777

REF.NO.

10-1909-8009-1609-6010-0609-1709-6B09-5209-5209-5209-5209-5209-5209-5209-6709-0410-1809-1709-3910-09

·10-0909-5209-1410-1810-1810-7't09-07(,9-0710-1~

09-3709-5509-5509-5509-3210-1309-06\)9-1209 7709-7009-5209-2109-1309-8309-4010-2109-73,,9-0"09-4010-1810-0410-0410-0409-1809-0910-1010-10

150846

PART NUMBER OESCR IPT toN REF.NO~

09-6309-7809-3109-1109-1109-0409-7009-1009-5109-5709-3009-1109-4409-2710-4310-4309-4510-0909-6409-1709-6109-1809-7609-7109-8309-8309-1909-5909-5210-7509-5509-0609-6009-7810-2109-5709-7610-1409-2109-6110-4110-0909-1309-1309-1309-1309-1309-4209-3110-1910-0610-43

. 09-4010-1810-1810-09

154511150881

PAD RUBBER ON PEDALCLIP PLASTIC FRONT PIPE TO CHASSIS SInE MEMBE'PIPE SUCTION CARBURETTOR TO OISTRIBUTORPIPE VACUUMPIPE THERMOSTATIC.VALUUM VALVE TO DISTRIBUTORFRONT SEALING BLOCK .SHIM DAMPING BETWEEN LINING PAD&PISTON L ~

SHIM DAMPING BETWEEN LINING PAD&PISTON R HWIRE WHEEL (LIME GREEN'WIRE WHEEL ALUMINIUM FINISHCLIP TUBES TO ENGINE BAY VALANCESLEEYE Y~CUUM PIPE .FRONT ENGINE MOUNTINGHOSE RETURN INLET MANIFOLDIREAR TO RETURNPIPEHOSE wATER HEATER OUTLET TO PIPE ASSYHOSE WATER INLET ISHDRTIBRACKET 3 WAY PIECE MOUNTINGLIGHT SWITCH HEADLAMP DIP AND FLASH R H 5

. BRACKET ASSEMBLY BRAKE PEDAL MOUNTINGFILTER ASSEMBLY IN-LINE PETROLCLIP CABLE RETAINING.CONNECTORCONNECTOR FLEXIBLECONNECT I CN 1.5 LONGGREASE pec 1 Ol TUBEGREASE peC 4 01 TUBELEVER THROTTLESHIM .004FLANGE PINION AND STONEQUARD ASSEMBLYLEAD EXTENSION GEAR LEVERBUSH RUBBER DAMPER EYEIUSE wITH ARMSTRONG DAMVAL YE EXHAUSTCLIP COUPLINGSLEEVE FRONT PIPELEAD EXTENSION WINDSCREEN WIPER AND WASHERNUT·ROAD WHEEL: (WIRF. WHEELS)FINISHER EDGE REAR PIPEGASKET LAMP SEATINGPLUG BUCKET TYPE INLET MANiFOLDBflLCRANK ASSEMBLYSTEERING COLUMN COWL ASSEMBLVCOVER IGNITION KEYRESTRICTCR HOSE TO CANISTERRESTRICTOR HOSE TO CARBURETTORT PIECEHOSE T PIECE TO ROCKER COvERHOSE EVAPORATIVE LOSS CANISTER TO T PIECEKNOB WOODENCONNECTICNCLIP P REVERSE LIGHTSWITCH LEAD TOP COV BOLTPULLEY ALTERNATOR .HOSE WATER MANifOLD TO VALVEGEAR 2ND SPEEDCABLE SPEEOO OUTERR H S.CABLE SPEECD INNER R H SHAlARD FLASHER UNIf

15'J88115093')15110315110815110915113415119115119215153415153515118415218415223115252115Z 523152525152602152616152823152961153041153138153141153153153245151317153417153516153671153726153757153881>153957153960153984154028154031>15404915405315411715417715'>18015420915421015421115421315lt21415423815428015429515433415t,.40515'>4791545200l'H5201154577

PART NUMBER

15ltB2115lt 8291548331%9211549251549451549771 %98515503J15503815508315508b155125155126155170155173155191155249155306155301155308155309155310155351155310155311155374155416155418155lt30155495155ft96155569155621.15566')15515115515315515515515615579915580015580115580515580615580115580815590615590115592115592815593015595915597815598315598lt155<}85

DESCRIPTION

GEAR 1ST SPEEDGEAR CLUSTER COUNTERS HAFTCOVER HARNESSSHIM ADJ DIFFERENTIAL BEARING(~OC92 1.0098SHIM ADJ OIFFERENTI~L BEARINGI.019 I.O~1 ISHAFT REVERSE ACTUATORTUBE .ANT!-TORQUE ASSEMBLYKNOB GEAR LEVER ASSYKNOB GEAR LEVER & SWITCH ASSEMBLYTUBE 01 STANCEPIPE ASSW PETROL TANK .TO CONNECTO.SCREW SOCK BUTT HEAD UP&lOW CLAMPS&TRIP PLATESPACERRAIL CHRLMEHOSE fILLER TO PETROL TANKLEVER HANDTR IP FL EX SPEEOOSL~EVE DISTANCE SILENCER SU_PORTBRACK ET STOwAGEU BOL TBRACKET CLAMPBRACKET !!OlJNT ING ANTI ROLL BARBUSH RUBBERNUT CRANKSHAFTSTRAINER AND SUCTION PIPE ASSEMBLYNUT SUCTION PIPE AND STRAINER LOCKINGCOVERSUCTlQN PIPE NUl AND STRAINER ASSYSIOE&FIASH DIRECT INDICAT(AMBER FLASH&WHITESIDE&flASH DIRECT INDICAl UIMPIUSATYPflAMBERWHEELBOX ASSEMBLYWINDSCREEN wIPER AND WASHER SwIfCH (2SPEEOIWINDSCREEN WIPER AND WASHER MOTOR SWITCHDRIVEN PLATE CLUTCHSTEERING COLUMN UPPER ASSEMBLYPLUG OIL DRAIN (MAGNETICINUT ROAD WHEel DISC WHEELSWASHER ReAD WHEEL NUT TRIM RETAIN DISC WHEELSFLANGE MAINSHAFTWASHER E~D OF MAINSHAFTBUSH OPERATING SHAfTSPA.CERWASHER NYlONWASHER CENTRE BEARING TO MAINSHAFTWASHER CENTRE BEARING TO MAINSHAFTWASHER CENTRE BEARING TQ MAINSHAETWASHER CENTRE BEARINGTe MAINSHAFTBUSH RUBBER REARPISTON ASSEMBLY (GRADED f AND GlOUTER AXLE SHAFT AND FLINGER ASSEMBLYSHAFT YOKE ASSEMBLYRADIUS ARM ASSEMBLYBRA.CKET PIPE SUPPORTSTOP LIGHT SWITCH (OPERATED BY BRAKE PEDALIEXTENSION OVERDRIVE HARNESS R H S ONLYEXTENSION OVERDRIVE HARNESS L H S ONLyEXTENSION GEARBOX HARNESS

09-40G9-4110-4109-5209-5209-3910-itl09-It210-7910-4109-1610-4109-01

. 09-0709-7609-It210-1809-8\l09-4909-4909-'4909-4509-4909-0709-1009-1009-1010-lit10-lit10-1010-1610-1809-3409-5609-3109-5709-5709-4009-4009-4209-It209-It209-ItO09-4009-4009-4010-1009-2309-5109-5109-5509-1610-1910-7510-7510-75

15it821 155985

PART NUMBER

15&02415603215603915&04015&04415608215(,08315&08415H701561 Bil151>1901562161562171562631 '56264156275156216156290156300156301156301156308156 30915&3161156~160

15631111563110IS!> 31B I15t>318015&32615633315H3615!>3421 Sf> 3441563451563791564641565111505331565351%5491565511565591%572156580

.1%5811566051%60715£>608156112156736156903156910156911156952151>968

DESCR IPT ION

CLAMP ASSY RACK & PINION BODY TO FRAMEGEAR SPEEOO DRIVINGPEDAL ASSEMBLY BRAKEPEDAL ASSEMBLY CLUTCHSWITCH HAZARD WARNING LIGHT L H S ONLYSHIM ADJ DIFFERENTIAL 8EARING{.0025 1.0035 ISHIM AOJ OIFFERENTIAL BEARINGI.0045 1.0055 }WASHER THRUST FITTED TWEEN 2NO&3RO SPEED GEARPAD CENTRE STEERING WHEELPEDAL ASSEMBLY ACCELERATCR R H SBRA(';Kl"T ASSEMBLY ACCelERATOR MOUNT[ NGACCELERATOR PEDAL & MOUNTING 8RACKET ASSY RHSACCELERATOR PEDAL & MOUNTING BRACKET ASSY LHSBRACKET ~ORN MOUNTING l HBRACKET hORN MOUNTING R ~

BR4CKET hORN MOUNTING l hBRACKET hORN MOUNTING R HLEVER THROTTLE AND CONNECTING ROO ASSEMBLYPEDAL STOP R H SPEDAL STep L H SWIPER ARI" R HWIPER 4R .. l HWIPER BLADECABLE SpEEOO INNER L H SCABLE SPEEOO OUTER L H SCABLE SPEEDOMETER INNER R ~ $'CABLE SPEEDOMETER OUTER R H:SCABLE SPEEDOMETER INNER l W S 'CABLE SPEEDOMETER OUTER l H SHANDLE JACK

. WATER EleowBOLT SELF LOCK CLUTCH HOUSING TO GEARBOX CASEACCELERATOR CABLE ASSY R H SACCELERATOR CABLE AS5Y L H SACCELERATOR CABLE ASSYHOSE WATER CYLINDER HEAD TO VALVELINK ALTERNATOR ADJUSTING & FRONT EYETUBE DISTANCE CLIP TO ENGINE BAY VALANCEBRACKET THROTTLE liNKAGE MTG & BELLCRANK ASSYLINK BEllCRANK TO THROTTLE LEVERSTEERING COLUMN UPPER ASSEMBLY (SWEDEN)STEERING COLUMN COWL ASSEMBLYTUBE ANTI-TORQUE ASSYLINK BELLCRANK TO THROTTLE lEVER

, STRIP SEALING FRONT COVER TO BACK PLATEOIL FILTER ASSEMBLY IALT TO GFE 119}T PIECEFUEL TRAP ASSYSLEEVE STRA IGHTCLIP FUEL TRAP TO BRACKETeLlp HOSE ATTAC&SPACER PINION BEARING (COLLAPSIBLE IBUSH H"'Nt; lEVER ,SLEEVE ASSY SYN & OPERAT 1ST 2NO&REVERSE GEARCONNECTOR FUEL PIPESLEEVE SYNCHRO & OPERATING 3RD/TOp ASSEMBLY

REF.NO.

09-5609-4009-6409-6310-1809-5209-5209-4009-5809-6009-6009-6009-6010-0910-0910-0910-0909-3109-6009-6010-1010-1010-1010-1810-1810-1410-1810-1810-1809-8309-0909-3809-6009-6009-6010-4309-1609-3009-6009-6009-5810~ltl

10-4109-6109-3009-2609-3109-1209-1209-1209-2'709-5309-4209-4009 7709-40

156024 156968

PART NUMBER

151>98115706515106915108215719215.72291514C91514141574161575GB15151C1 5151~1575551517321SaOQZ158003158072158080158137115813721581381158136215819615820915823&1582931583061583711583721584591584911584931584-9/>1585011585091585111585231585261585341585541585611585621585631585641585651585661585671585661585751585B5158590158729158732158734158830158858

OESCRIPT ION

WASHER CCPPER COOLER PIPE TO ADAPTORBRKT THROTTLE RETURN SpR INGIF ITTED TO EXHAUSTWASHER JOINT CARBURETTORS TO MANIFOLDPETROL PIPE FRONT TO REAR CARBURETTORPEDAL ASSEMBLY CLUTCHSPRING VALVE (SINGLEIRING SEALIUSE WITH AUTOMO PROD'FILTER 1565811RING SEALING USE WITH A C DELCO FILTER 1565BlSPRING VALVE INNERPUSH RODCOLLAR VALVF LOWERUNION CoeUR PI'PE TO AOAPTORLEAD EXTENSION NUMBER PLAiE LAMPBALL BEARING MAINSHAFT IN END OF EXTENSIONBRKT OVERDRIVE INHIBITOR SWITCH&SEAl SENSORSTUD TOP COVER EXTENSION ATTACHMENTAC TUA TOR SW nCHRELAY LEVER ASSEMBLYHORN HIGH NOTE LUCASHORN LOW NOTE CLEAR HOOTERSHORN LOW NOTE LUCASHORN HIGH NOTE CLEAR HOOTERSGASKET LAMP SEATINGFLASHER UNITIGNIT ION SWITCHLABEL APPROVAL ODOR LOCKS HINGES & STEERINGAOAPTORGEARBOX I'ARNESS L H S (U S AIEXTENSION OVERDRIVE HARNESSSWITCH IGNITIONLEAD EXTE~SION FLASH!R uklTCOVER TOP SUB ASSYWARNING LIGHT FASTEN SEAT BELTSDIODE ENCAPSULATEDBUZZER IGNITION WARNINGCANISTER SEPARATORCLIP SEPARATOR CANISTER TO TANK FLANGERESTRICTCR CANISTER PIPESWITCH SEAT SENSOREND CAP VENT PIPESIDE MARKER ASSEMBLY FRONT IAMBERI R HSIDE MARKER ASSEMBLY FRONT (AMBERI L HSIDE MARKER ASSEMBLY REAR IREDI R HSIDE MARKER ASSEMBLY REAR IRECI L HBODY IBLACKI R HBODY (BLACK) L HBODY IBLACK) R HBODY (BLACK) L HSTRIP FLEXIBLE SILENCER TAIL PIPE MOUNTINGWASHER PLAIN BETwEEN REVERSE ACTUATOR&TOP COVCLl I' END CAPWHEEL STUDBALL JO INTFUSE ASSV IN-LINE MAIN BEAM IBLUE/WHITEIIGNITION COILFUSE ASSY IN-LINE DIP BEAM IBLUEfREOI

10-8409-6009-:n09-3109-63()9-0609-1009-1009-2209-0609-06'10'-8410-1609-3109-4209-3909-4209-6810-0910-0910-0910-0910-1510-0910-0910-1209-6210-2110-7410-0910-0909-3910-1610-2110-1909-1809-7809-1810-6709-7610-1.410-1410-1510-1510-1410-1410-1510-1509-8009-3909-1609-4109-5910-1310-041'0-'13

156981 158856

PART NUM8ER

1589171589401589411589661591221591231591301591311591391592551593,6915'131215939415'139715941315941415950315950515956515960415960615964015'164115964315964415'165315973315973715976115978415980115980715,'1814159816159338159842159843159881159893

, 159894" c'1'59905

15993915'H4.?1 599781 6)018

160021160J2216003816:1.)7916JlG81M121

,16019416n021602191602.23

OESCR IllT ION

WARNING LIGHT SIDE LAMPCYLINDER UNERCYLINDER L1 NERFLASHER INDICATOR SWITCH (L H 51PISTON ASSEMBLY GRADED f & GROO ASSY SPRING RETAININGCAL IllER ASSEMBLY FRONT 8RAKE ItESS PAOSI R HCALIPER ASSEMBLY fRONT BRAKE (lESS PADSI L HREAP, DAMPERPUSH RODGASKET ACAPTOR MAIN CASECABLE ASSEMBLY COMPENSATOR-WHEEL CYLINDERNUT SPECIAl-NYLOC-HYPOID PINIONNIPPLE SPOKESPOKE LONGSPOKE SHeRTSPRING CLIPCAM SUB ASSEMBLYREAR ENGINE MOUNTING ASSEMBLYFUEL GAUGE (PANEL)TEMPERATURE GAUGEPIVOT BRACKET AND SPRING ASSEMBLYPIVOT BRACKET ASSEMBLYLEAD CONVERSION REVERSE LAMP FEEDLEAD EXTENSION SIDE LAMP WARNING LIGHTHARNESS OVERDRIVE & REVERSE LIGHT SWITCHBRACKET ASSY MOUNTING REAR BRAKE HOSETRIP FLEX (SPEEDOIHORN PUSH ASSEMBLYSWITCH OIL PRESSURECROWN WHEEL & PINION ASSY (3.89 1 RATIOIBRACKET ~OUNTING ANTI RUN ON VALVEHOSECLAMP CANI STERREAR NUMeER PLATE LAMP (U S AIPIVOT BRACKET ASSY RADIUS ARM L HPIVOT BRACKET ASSY RADIUS ARM R HHOSE INLET MANIFOLD TO ANTRI-RUN ON VALVEIDENTIFICATION LIGHT HAZARD SWITCHlOENTIF leATION LIGHT WIPER/WASHER SWITCHHAlAROSWITCH AND WARNING LIGHT ASSYBODY HARNESS L H S (U S AAoAPTORWASHER BETWEEN 3RD SPEED GEAR & CIRClIPWASHER BETWEEN 1ST SPEED SLEEVE&2ND SPEEOGEARSTRIP EDGE LIT HEATER ESCUTCHEONLAMPHOLOERCLIP MASKSTEERING WHEEL & PAD ASSYBULBHOLOER HEATER CONTROL ESCUTCHEONNUT,lOCK E G R VALVEBULB HEATER CONTROL ESCUTCHEONOVERORIvE HARNESSLEAD EXTENS10N HAZARD WARNINGSTUD REAR ENGINE MOUNTING O\lERDRIvEHOSE ·BOTTOM'

156917

10-1809-2009-0410-0909-0709-61

,09-7009-7009-'5509-2210-7809-6809-5309-5109-5709-5110-8010-8010-7810-1810-1809-5509-5510-2210-2210-7909-4510-1810-0909-0409-5309-7809-7809-7810-1609-5509-5509-1310-1810-1810-1810-2109-1409-4009-4010-3910-3910-3909-5810-3909-1310-3910-1'110-2210-7809-82

160223

PART NUMBER

16028616029810033116033516036316036416036520053520124620134420135020422621)6175206685206686208058208715208943209018209398209399209423209542209688209749209750209776209865210449211048211049

.2U126211710211794212006212')37212416212622212935213032213 680213681213 68921386321414421't538214814215104215350215372215531215823215936215975215997215998

nES l:R I PT ION

l:OUPL ING FLANGEMOUNTING PLATFORMOVERDRIVE HARNESS IU S AIEXTENSIO~ LEAD REVERSE LAMPSPOKE LONG ICHROMElSPOKE sHCRT ICHROME)NIPPLE SPOKE (CHROMEISTARTER ~OTOR

BRAKE DRUM REARREAR ENGINE PLATEGEAR RI NGREAR HUB INNERBOSS SLA~E CYLINDERLOWER WISHBONE ASSEMBLY R HLOWER WISHBONE ASSEMBLY L HRACKFRICTION DISC FRONT BRAKE CALIPERCROSS MEMBER AsSY REAR DAMPER MOUNTINGPLATFORM REAR ENGINE MTGOUTRIGGER ASSEMBLY FRONT R HOUTRIGGER ASSEMBLY FRCNT L HBEARING ASSEMBLY STEERING COLUMNGAUGE UNIT PETROL TANKSTEERING COLUMN LOWERSTAY ASSEMBLy RADIATOR R HSTAY ASSEMBLY RADIATOR L HPIPE ASSY RETURN INLET MANIFIREARITO WAT PUMPCRADLE ASSEMBLY RADIATOR MOUNTINGCLUTCHOUSING AND FRONT END CDVER ASSYTIE ROD LEVER R HTIE ROD LEVER L HWASHER TIMING COVERELECTRIC WASHER AND BOTTLE ASSEMBLYCOOLER OiLOIL SUMP ASSEMBLYCLUTCH COVER ASSEMBLYPIPE BRANCHEO Assy HEATER WATER RETURNOIL SEAL HSG REARPIPE ASSY 8RANCH RETURN INLET MANIF{REAR ITO IICLUTCH DISENGAGING LEVER ASSEMBLYSHIELD OUST R HSHIElO DUST L- H"BRAKE MAST CYLCTANDEM1ASSYlLHSlFIT TO SPECIALSUMP ASSEMBLYSPRING ROAD FRONTCOVER CLUTCH ASSEMBLYROOKER ceVER ASSEMBLYVALVE ASSEMBLY PRESSURE DIFFERENTIALWASHER JOINT FRONT ENGINE PLATEfRONT ENGINE AND MOUNTING PLATE ASSYPLATE MOUNTING REAR AXLE ASSEMBLYGASKET BASEPIPE VACUUMfUEL PIPE 5/16 X 64.50FUEL PIPE PUMP TO CARBURETTORPIPE FRONT REAR PIPE CONNECTION TO CANISTER

160286

10-8210-7310-7910-7909-5709-57(.19-5710-0109-1009-0509-0709-5109-3109-4809-4809;'5909-7009-4509-4409-4509-4510-41OQ-7609-5809-8209-8209-2709-820"1-3809-4709-4709-0810-1210-8409-0509-3509-2709-0509-1409-3809-1009-7009-6109-0501-3209-3409-2209-7309-0509-0509-5210-1609-1209-7609-1809-18

215998

PART NUMBER

215999216006216011216012216112216449121644922166112166142166842161.5521b91521692421692421693221693321693421693521b939211033217058211073217251217314217333217383217384217430217431217465211589211 59021159121761421161821763621775121718921719021782021782221785521794921814221814321816121852621852121881521881&218835218944218959218982218996219010

OESCR IPT ION

fUEl PIPEPIPE CONNECTOR TO FLEXIBLE CONNECTIONPIPEFUEL PIPE PUMP TO CARBUREfTORNIGHT DIMMING RELAYSTEERING COL LOCK&SWITCH ASSY(WASO TYPEISTEERING COL lOCK&SWITCH ASSYIWILMOT 8REEOENCONSTANT PINION SHAFTGEAR 3RO SPEEDCROSS MEMBER fRONT VALANCE SUPPORTROCKER COVER ASSEMBLYSCISSOR JACKHOSE ROCKER COVER TO T PIECEHOSE T PIECE TO CARBURETTORSTOP/TAIL FLASH REfLEX&REV~RSE LAMP RHIRED/STSTOP/TAIL FLASH REflEX&REVERSE LAMP LHIRED STSTOP/TAIL FLASH REFLEX&REVERSE LAMP RHIREO STSTOP/TAIL FLASH REFLEX&REVERSE LAMP LHIRED STHOUSING SEARING ASSY (WITH PULLEYIANTI-ROll BAROIL PUMP ASSY «WITH STRAINERIPROPELLOR SHAFT FRICTIONLESWIRE WHEEL (BOLT ONIMAINSHAFTGEARBOX EXTENSION ASSEMBLYPROPELLOR SHAFT STRAP DRIVE (OVERORIVEIPROPELLOR SHAFT STRAP DRIVEBRAKE PEDAL AND MOUNTING BRACKET ASSEMBLYCLUTCH PEDAL AND MOUNTING BRACKET ASSEMBLYPEDAL ASSEMBLY ACCELERATOR L H SDAMPER FRONTFRONT OA~PER & ROAD SPRING COMPLETE ASSYDAMPER FRONT (HEAVY DUTY)TOWING ATTACHMENT KIT REARFRONT OAMPER&ROAD SPRING CQMP ASSYIHEAVY CUTYPLA TE BACK AS SEMBL YGASKET CYLINDER HEADPUllEY CRANKSHAFTTIMING ceVER ASSEMBLYCOVER ASSEMBLY FRONT (AIR BOxl"AIR CLEANER AND SILENCER ASSEMBLYPIPE TANK TO CANISTERCLUTCH PEOAl&MDUNTI NG BRACKET ASSEMBLYcn HEAD ASSY HIGH COMPlLESS VALVES & SPRINGSCYL HEAD ASSY LOW COMPILESS VALVES & SPRINGSBATTERYGUSSET MEMBER VALANCE ASSY R HGUSSET MEMBER VALANCE ASSEMBLY L HSPEEDOMETER MILESPEEDOMETER KILOREV COUNTERPROPELlO R SHA FTIGNIT ION SWITCHBRACKET ASSEMBLV DAMPER SUPPORT L HCHARCOAL CANISTERBACK PLATE ASSEMBLY R H

09-7709-1609"'7609-3110-0909-5809-5809-4109-4009-4509-0609-8309-3109 1310-1510-1510-1510-1509-0909-4909-1010-7509-5109-4009-3709-5109-5109-6409-6309-6009-4809-4809-4810-1309-4809-3009-0609-0109-0809-3009-3009-1109-6309-2209-2210-2009-4509-4510-1810-1810-1809-5110-0909-4509-1809-70

215999 219010

PART NUMBE~ 'DESCRIPTION REF. NO.

BACK PLATE ASSEMBLY L HBRACKET ASSEMBLY DAMPER SUPPORT R HREAR BRAKE ASSEMBLY R HREAR BRAKE ASSEMBLY LHINLET MAIIIFOlDREAR CROSSMEMBER & AXLE MOUNTING ASSYSTEERING COL lOCK&SWfTCH ASSYIWASO TYPEIAUDISSTEERING COL lOCK&SWJTCH ASSYlwIU40T BREEOENIGNiTION COil 12V IA C·DElCOIBRKT ASSY REARAXlE MTG&HANDBRAK CASLE GUIOELHBRKT ASSY REARAXLE MTG&HANDBRAK CABLE GUICERHHOSE & VACUUM WITH ASSYALTERNATCR 116 ACRIWITH FAN & PULLEYADAPTOR GEARBOXBRKT 4SSY FRONT SUSPENSION & ENGINE MTG R HBRKT ASSY FRONT SUSPENSION & ENGINE MTG l HRACK • P.INION ASSEMBLY L H SRACK & PINION ASSEMBLY R H SPIPE ASSY MASTER CYl TO CLUTCH SLAVE CYI LHSPIPE ASSY MASTER CYL TO CLUTCH SLAVE CYL RHSEXTENSION TOP COVERVERTICAL LINK R HVERTICAL LINK L HOVERDRI VE UNITMANIfOLD EXHAUSTMANIFOLD INLETPIPE 4SSW MASTER CYL TO CLUTCH SLAVE CYl LHSRACK&PINION ASSY LHSINORwAY&SWEOEN WITH GREASCRANKSHAFTFAN ASSY 17 BLADEIPLASTIC 12 1/2 OIA HOT CLIMPI·PE ASSY MASTER en TO FOURWAY CONNECT RHSPIPE ASSY THREE OR FOUR hAY TO R H FRONT HOSEPIPE ASSW THRfEWAY OR FOURWAV TO LH FRONTHQSEPIPE ASSW fOURWAY TO DOUBLE END UNIONPIPE ASSV REAR THREE WAY TO OOUBLE END UNIONPIPE ASSY MASTER CYL TO fOUR WAY CONNECT LHSPIPE ASSW TANDEM MAST CVL TO PRESS DIffER WARPIPE ASSY TANDEM MAST CYL TO PRESS DIFFER WARPIPE ASSY PRESS DIFFER VALVE TO 3WAv CONNECTPIPE ASSY PRESS DIFFER VALVE TO DOUBLE END UNPIPE ASSY WHEEL CYLINDER TO L H HOSE.PIPE ASSY WHEEL CYLINDER TO R H HOSEPIPE ASSW 3 WAY TO L H REAR HOSEPIPE ASSW 3 WAY TO R H REAR HOSECRANKSHAFT ASSEMBLYAIR CLEANER ASSEMBLYFAN ASSYll BlAOEIPlAST Ii 1/2 OIA NORM FITMEROAD WHEEL IDISCISKID PLATE ASSY (SPECIAL ORDERS DNLYICAMSHAFTPETROL PUMP ASSYPETROL TANK ASSYREAR SILENCER AND TAIL PIPE ASSEMBLYREAR SILENCER AND TAIL PIPE ASSEMBLYBRACKET ASSEMBLY PIVOT SUPPORT RHBRACKET ASSEMBLY PIVOT SUPPORT l H

2190112190372191)4721904821<}l)49219056219061121,}06122191002191522191532191872192673051373057463057473059313059323059363059373061523066033066(l4307862308086308081308160308173308737309141309699309700309701309702309703309706309712309713309714309115309172309773309774309175311553311 1>9631.1 702312046312183H2188312343312394

. 312461312502312509312510

219011

09-7009-4509-7009-7009-1409-4509-5809-5810-0409-4509-4509-8210-0610-7409-4509-4509-5909-5909-7209-7109-4209-4709-4710-7409-1409-2709-1309-5909-2309-090<1-110<1-7109-7309-7109-7409-1209-7309-7309-1309-7309-7409-7409-7409-7409-0709-1709-0909-5709-4509-0809-1509-7609-8109-8009-4509-45

312510

PART NUMBER

313085313143313 23131323231326831327331327431330540215940282340306650005150009850017250Cll8650022150030950041250:l4645004695005685005875005915005945006135006335006425008725008925C()9265009215009745011965012585016515017045017065017085017095'01710501 711501712501714501715502136502146502148502210502470502550502559502560502789503213503438503467

OESCR IPT ION

ADAPTOROVERORIVE UNIT (J TYPE'CARBURET TOR ASSEMBLYDISTRIBUTOR ASSEMBLYMAIN HARNESS (U S Al~AiN'HARNESS L H SMAIN HARNESS R H SOVERDRIVE UNIT (J TYPE'FUEL PIPE 5/16 X 59RAD IATORBLQC K ASSEM8L YCHASSIS FRAME ASSEMBLYWASHER LOCK HARD TOP TO REAR DECKNIPPLE GREASEWASHER PLAIN SUPPORT BRACKET TO FLOORRING SNAP HANDBRAKE LEI/ER&RATCH TO MTG BRKTWASHER PLAIN TIE BAR TO BODY SIDEWASHER PLAIN SUPPORT BRACKET TO fACIAPIN LEVER TO SHAFTWASHER CCPPER CLUTCH HOUSING HI GEARBOX CASEWASHER CCPPER ROCKER OIL FEEDWASHER VALVE PLUGBRIDGE PIECE KITPLUNGER BALL VALVEo RINGWASHER "'RUSTSPRING FeR PLUNGERWASHER TAB SECURING THRUST BEARING HOUSINGCIRCLIP FITTED ON SHAFTPINION & SLEEVE ASSYBUSH COM~UT ATOR BRK T 0I ECASTCOMMUT END BRKTBUSH DRIvING END BRACKETPIN MILLS ATTACHING GEAR TO SHAFTWASHERWASHER RETAIN PISTON & SPRING IN BLOCKWELlSE4L JOINTING COMPOUND CYL HEAD TO BLeCKCAP SHAFT ENDBRK ASSY COMMUTATOR END DIE CAST COM END BRKTSPRING SET BRUSH TENSION DIECAST CO I'M END BKTNUT lOCATINGSPRING MAINSPRING PINION RETAININGBRACKET ASSEMBLY DRIVING ENOARMATURE ASSEMBLYCOIL FIELD NETWASHER PLAIN ON BOLTWASHER PACKING UNDER REVERSE LIGHT SWITCHWIRE LOCKING BOLTBOLT THROUGH END BRACKETSSCREW SIT TRIM PAD ATTACHMENTROLLERS STEEL IN CAGECAGE ROLLERBREATHERSETSCREWSLEEVE PVC FITTED TO BRAKE PIPE CLIPWASHER LOCK TIE BAR TO BCDY SIDESCREW SIT

REF.NO.

, 10-7810-8009-1810-0410-2110-2110-2110-7809-7609-8209-4510-5409-4710-4009-6810-5710-4010-.76O'9-aa09-0510-7610-8010-7610-7610-7710-7610-7709-4010-071'0-0710-0709-08

, 09-3409-0409-0610-0710-0710-0710-0710-0710-0710-0710-0710-0709-5810-1909-5810-0710-591()-7710-111<1-7610-3509'"7410-4010-34

313065 503467

PART ,NUMBER

50360450362350362750362.850396950486350'>87750'>87850'>8895050315052.5950530650530750577150604'>506063506066506067506070506071506076506081

• 50!>0825060835060845060915060915060'1850609950610150bl03 '506t04506105506107506108506109506111506112506113506114506115506111506118506119506129506130506155506157

, 50654250655950673150708650800750801750813'1508185

DESCRIPTION

CROSSHEAO & RACK·SETSCREW FRONT NUMBER PLATE ATTACHMENT USANUT BEllER, ATTACHMENT~ASHER PLAIN fRONT NUMBER PLATE AITAtH USASCREW SECURING JET BEARING IN BODYSPINDLE & ROTOR ASSEMBLYSPRINGWASHER ClPPLATE RETAINING WHEEL CYLINDERCLIP PIPEWASHER LOCK HOOD FRAME~TG PLATES TO BODY

,WASHER PLAIN LOCKING LEVER TO PIVOT BRACKETWASHER LOCK CABLE CLAMP ATTACHMENTNUT SECURING WATER VALVE TO BRACKETSUNWHEEL ASSEMBLYROLLER SETBEAR [NG ASSEMBLY SPEEDOMETERSPEEDOMETER, DRIVE ASSEMBLYSPRING VALVESCREW LOCKINGSCREW RETAINING PUMP BODy

,HOUSING CLUTCH THRUST BEARINGSTUD 1/4 REAR ~ASING TO'MAIN CASINGSTUD 1/4 MAIN CASING TO GEARBOXBRIDGE PIECE CLUTCHRING SNAPPLATE SIDE COVERJOINT FOR PLATEGEAR DRIVING ON MAIN SHAFTJOHNT PAPER

,STUD 1/4' REAR CASING TO'MAIWCAS]NGPLATE RETAINER CLUTCH THRUST BEARINGSTUD 1/4 MAIN CASING TO GEARBOXPLATE SEALING OIL FILTER TO CASINGWASHER ON LOCKING SCREWSIDE COVER PLATEBEARING BALL FRONT ANNULUS SUPP IN REAR CISINBEARING BALL CLUTCH THRUSTBEARING NEEDLE ROLLERPLUG DRAINo RINGPLUG VAL VEWASHER FeR PLUGGEAR DR I VENo RINGo RING ON PISTON OPERATING CLUTCHNUT HEX FRONT NUMBER PLATE ATTACHMENTNUT JAM LOCKING KN08 & lEVERCIRCL IP PEOAL TO MOUNTING BRACKETSEAL'SETSCREW WASHER ATTACHMENTSCREW SECURING UNIT RETAINING. PLATEeIRCLIP RETAINING SPRING ON PINSCREW SECURING SUCTION CHAMBER TO BOOYHOLDER ,BULBCLIP CABLE

503604

REF.NO.'

10-10la-5109-5B10.,.51O"}-3209~10

09-70·09-70O"}-7009-1210-51

, 10-6810""4210-4310~77

10-81, ,'10-71

LO..,7710-7610-1710-76

,10-7710-7610-7610-7710-71,10-7610-7610-77

:,10-7610-7610-7710,..7610.,.1610-7710-7710-7710-17

·10-7710-7610::-7710-.7610-7610-77

, '10-7610-7710-5109,..4209-6309-7010-1210-1309-3209-3210-1910-04

50BIB5

PART NUMBER

512 BOl512B025128035130635131955i3196513198513199513200513201

. 5 Han;?. 513203

513 204513 20551} 206513 207513208 .51320951321051321151321415132142513 21435132144513 215513216513219513220513222513223513224513225513226513227513228513229513231513266513267513400

·51368751361'1851368951310751}888513,897513971513993513999514023

.514024514025514026514064:5140B2514124

DESCRIPTION

STEM VAL \IESEAL VAL VI;WASHER SPRING VALVE HEADSCREii BLEEDANNULUS jSSEMBLVOIL PUMP PLUNGER ASSVREAR CASING ASSEMBLVSPRING CLUTCHCLUTCH SLIDING MEMBER ASSY (WITH LININGSIWASHER JOINTOIL F IL TERBOLT SECURING THRUST BEjRING HOUSINGWASHER JClNTMAGNE T F IL TERPLUG VAlVESPRING VALVESPR 1NG FeR CAGEFLYWHEEL INNER MEMBERRING SPRINGTUBE SPACING ON ON MAIN SHAFTADJ,WASHER CORRECTING END FLOAT (.105ADJ WASHER CORRECTING END FLOAT (.100ADJ WASHER CORRECTING END fLOAT (.095ADJ WASHER CORRECTING END FLOAT 1.090PLATE RETAININGCAM OIL PUMP OPERATINGSPRING PISTON OPERATING CLUTCHPISTON OPERATING CLUTCHBODY PUMPRING SPR ING

. BEARING NEEDLE ROLLERSCREW SE I.SECUR ING SOLENOIDSCREW HEX SECURING SIDE COVE~ Pl.TENUT SECURING THRUST BEARING HOUSINGRING CLUTCH BRAKEBEARING BALL REAR ANNULUS SUPPORT IN CASINGOIL SEALSPRING FIXING SEATING RIMSCREW TR IMMERCLIP CAPNUT THROTTLE STOP&fAST IDLE LEVER TOSPINCLEWASHER SHAKEPROOF THROTT STDP&FAST IDLE LEVER01 SC THRCTTLERING DIAPHRAGM RETAININGDOWEL SPRING CAM LEVER TO SHAFTBAll BEARINGRING SEALING ADAPTOR ATTACHMENTEARTH LEADSCREW CAP ell PSLEEVE SCREWEDCUP SHAFTBUSHING & BEARINGARMATURE ASSEMBLYWASHER RIM FIXINGENGINE OIL COOLER KITBATTERY CIlY CHARGED 12V - 40 AMP

512801

REF. NO.

09-6609-6609-/)609-3410-7710-7610-7710-7610-7710-7710-7610-7710-7710-7610-7610-7610-7710-7710-7710-7710-7710-7710-7710-7710-7710-7610-7610-7610-7610-7710-7710-7710-7710-7610-7110-7710-7710-1310-1310-0509-1909-1909-1909-1910-7610-8210-8410-0510-0510-0710-0710-0710-0710-1410-S410-20

514124

PART NUMBER

5142005142,)851420'1514210514211514212514213514,214514'223514265 '51426851430251443851't639514 1>9851471351471451471551471 q51477751488951500251502051504551<;04651506051506151511251511851514951515251515451518151518251518951522551524351525851521951529151529'351529951536951540951581 (;5158n515812515813515814515815515816515811515818515825515821515813

DESeR IPT ION

SCREW ASSEMBLY SOLENOID ADJUSTINGMOTOR COVER AND PUMP ASSEMBLYMOTORBRUSH SETARMATURECOVER ANC PUMPBOTTLECAP FIll ERBRACKET ~OUNTING & STRAP ASSEMBLYHEADLAMP ASSEMBLYHEADLAMP ASSEMBLYSPECIAL 'GIL GEARBOX TOPPING UP 1 PINT TINWASHER PLAIN PETROL 'TANK CASING BOARDSPECIAL GREASE AXLE SHAFTILB TINPIV SHOULDER DIAPH SPRING&FULCRUM RING TO COVPIVET CLIP & STRAP TO PRESSURE PLATEPLA TE PR ESSUR ECLIP RETAIN DIAPH SPRING ON PRESSURE PLATESPRING DIAPHRAGM CLUTCHWASHER LCCK TIE BAR TO BOOY SIDEPIN SPRING SUPPORTCLIP HARNESS TO ENGINE 8AY VALANCECUP SHAF TPIM UNIT SEAl'INGUGHT UNITGROMMET CABLE ENTRYGROMMET CABLE ENTRY FLASHERDAMPER ASSEMBL VPLATE RETAINING LIGHT UNITSCREW BL EEOOUST COVER WHEEL CYLINDER\'IGDY·PLUNGER CYLINDERSEAL GLAND PLUNGERBATTERY ORY CHARGEO 12V - 56 AMPPIVOT PIN & SCREW ASSEMBLY CHOKE INNERLABEl IDENTlTYSERVICE KIT BRAKE MASTER CYLINDERSETSC«EW SUPPORT BRACKETSERVICE KIT SLAVE CYLCOVER DUST OVER END OF BeDYRETAINER OUST COVERNUT MANIFOLD EXHAUST PIPE TO MANIFOLDCONNECTOR DOUBLE SNAPVALVE BODY ASSEMBLY NON-RETURNSHAFT VALVE OPERATINGLEVER CAMOPERATING VALVE LEVER ASSEMBLYFRONT CASING ASSEMBLYPLANET CARRIER ASSEMBLYRELIEF VALVE KITNUT SLOTTED SECURING COUPLING FLANGE TO ANNULWASHER PLAIN SECURING COUPLING FLANGEROTORRESISTORLEAD BATlERY POSITIVE Te SOLENOID

514200

10-7710-1210-1210-1210-1210-1210-1210-1210-1210-1310-1309-8310-6009-8309-3409-3509-3509-3509-3510-5710-1610-1810-0810-1310-1310"-1410-1409-1910-1309-100·9-1010-1609-6609-6610-2009-3109-3209-6610-4009-3409-3409-3409-8010-2210-1610-7610-7610-7610-7610-1710-1610-7110-7710-4210-421'0-20

515873

PART NUMB ER

515900515901515 '19751599951600551604151606451607951610751621251621351621451621851621951622151622251622351622451622551622651&2415l!J24251&24751625751627751&288516304516305516506516591516592516614516762510835510945516948516952511>9605159015169055109715169725169735'16974510975510976516980516981516983516988516989517009511010517011517012517020

DESCR IP TION

FRONT SUSPEN UNIT LH FITTED WITH GREASE NIPPlFRONT SUSPEN UNIT RH FITTED wITH GREASE NIPpLLEAD 8ATT NEGAT TO BODY TO ENG EARTH LEAD lHSLEAD BATT NEGAT TO BODY TO ENG EARTH LEAD RHSWASHER NEEDLE VALVEGROMMET CABLE ENTRYLEAD STARTER TO SOLENOID L H SROD CONNECTION & LEVER ASSY CHOKE OPERATINGLOCTITE STUDLOCK FILLER INSERTPISTON fITTED IN CALIPER BODYSPRING DIAPHRAGMRING DIAPHRAGM SPRINGCAP FILLER RESERVOIRRESERVO I RWASHER PLAIN RESERVOIR Te ADAPTORNUT JAM RESERVOIR TO ADAPTOR .SPA I NGPLUNGERCIRClIPROD PUSH ASSEMBLYCOVER DUST CYLINDER ENDLEVER THROTTLE RETURN REARLEVER THROTTLE RETURN FRONTLID FLOAT CHAMBER ASSY REAR CARBURETTORCLIP CLUTCHPIPE TO PRESS DIFFER VALVE LHSONLYSERVICE KIT BRAKE MASTER CYLINDERSETSCREW SUPPORT BRACKET TO fLOOR (fRONT)RIMSCREW RIM FIXINGCOVER FUSE BOXNUTWASHER LOCKNUT JAM HOSE ATTACHMENTWOODSCREWBOLT FLOAT CHAMBER TO BODYSPRING AIR VALVE RETURNSP INOlE THROTTLESCREW SECURING DISC TO SPINDLESCREW SECURING STARTER TO MAIN BODYWASHER SHAKEPRooF STARTER TO MAIN BODYSCREw FAST IDLE AOJIJS1MENTSEAL LARGE ON COMPENSATOR BODYSEAL SMALL INSIDE CARBURETTORSCREW COMPENSATOR ATTACHMENTWASHER SHAKEPROOF COMPE~SATOR ATTACHMENTSCREW IDLER TRIMMINGSPRING IDLER TRIMMING SCREWGASKET FLOAT CHAMBERFLOAT CHAMBERSEAL THROTTLE SPINDLEo RING DAMPERLU8A I CAT ION PACKSCAEWClIP PRESSURE PLATEWASHER TABPLATE PRES SUR ECOVER DUST

515900

09-4709-4710-2010-2009-1910-1410-2109-3109-7709-7009-3409-3409-6609-6609-6609-6609-6609-6609-6609-6609-3209-3209-32 .0'l-7309-6610-4010-1410-1410-1910-0710-0709-7110-3909-3209-1909-1909-1909-1909-1909-1909-1909-1909-1909-1909-1909-1909-1909-1909-1909-1909-1909,..3409-34

·09-3409-340'9'""67 .

517020

PART NIJMB ER

5170215170225170235170285170295170305170315170325170335170345170355170365170375170385170395170405170415170425170435170445170455170465110485170505171105171195171345171455171895171'165172015172375172.63517264517294517333511352517386517453517621511643517644517645517650517651517652517653511655517657517700517767517183517840518031518032518041

DESCRIPTION

PLUNGER PRIMARYPLUNGER SECONDARYSEAL RI NG TWO-W.AYSPRINGSTEM VAL liERETAINER SPRINGSPRINGSPACERTIpPING VALVE ASSYSEAT VALliESPR ING VALVECIRCLIPNUT VALVESEALRESERVOIR FLUID ASSYCAP FILLERBAFflEGASKETSEALSnSCREWWASHER SPR I NGPUSH ROO ASSEM8LYCOVER & STRAPS SUB ASSE~BLY

INSULATORCLIP STARTER CONTROL BRACKETSCREW SECURING DIAPHRAGM RETAINING RINGPIN FLOAT PIVOTSETSCREW LONGLOKBOLT THROUGH FRAMEELEMENT AIR CLEANERRETAINER TRIMMER SCREWSUNDRY PARTS SETWASHER PLAIN HARD TOP TO HEADER RAILWASHER LOCK HARD TOP TO HEADER RAILSPRING VALVE NON RETURNSERVICE KIT RESERVOIRCOIL AND IGNITION LEAO KITSETSCREW WARNING BUZZER ATTACHMENTNEEOl l' VAL VEWINDSCRE£N WIPER MOTOR (TWO SPEED IARMATUREBRUSH ASSEMBLYSW ITC H PARK INCBRUSH BOX ASSEMBLYICOMPLETE WITH BRUSHES)BRUSH SETROTORSLI P PI NGSERVICE KIT DRIVING END BEARINGBEARING KIT SLIP RING ENDSERVICE KIT TANDEM MASTER CYLINDERGASKET BY-PASS VALVEWASHER PlAINHEAOlAMP ASSEMBLYLENS l HLENS R HRULBHOLDER STOPITAIL

517021

REF~!'.lQ.

09-6709-6709-6109-6109-6109-6109-6709-6109-6109-6109-6109-6709-6709-b709-6109-0109-6709-6709-b709-.6109-0709-6109-3510-0509-1909-1909-1910-5410-0609-1610-1310-0610-4510-5710-7609-6710-0410-1909-1910--1010-1010-1010-1010-0610-0610-0610-0610-0610-0009-6109-1910-4010-13

·10-1610-1b10-15

518041

PART NUMBER

518042518:1835181105B27J5183135183145134285184295164'30518434518°'1'395184405184805Hl52851852951658351858451858551865351880851884251884451888?51988451888651888751888851889,)518896513903518904518920518926518930518931

° 51893751893951894G51899051904751905051905151918851921551932451932551'135851936451936551940651940751940'151955151'9566519511>519582

OESCR IPT roN

eULBHCLOER FLASHER & REVERSESCREW MIRROR STEM TO HEADCAGE fR EEWHEELSCREW SIT NUMBER PLATES TO REAR 8UMpERCABLE IN~ER CHOKE CONTROL WITH KNOBCABLE OUTER CHOKE CONTROLSCREW LONG&SPR WASH fIX fLOAT CHAMB TO MAINBOSCREW SPRING WASHER BY-PASS VALVEWASHER SliAKEPROOf CARBURETTORSERVICE KIT A PACK (YELLOW.SCREW COUNTERSUNK BY-PASS VALVE TO MAIN BODYBOLT SAFETY HARNESS COVER HARD TOPMOTOR & ~OUNTING SHELL ASSEMBlVSCREW SECURING BRKTWASHER TAB LOCKING SCREWSBOLT SHOULDER AIR CLEANER TO CARBGASKET UNDER BOLT HEADWASHER UNDER BOLT HDSCREW SECURING METERING NEEDLEBULBSERVICE KIT B PACK IREDICROWN WHEEL & PINION ASSEMBLY (3.89 1 RATIOIWASHER TAB SECUR LEVERS TO THROTTLE SPINDLESPRING RETURN CAM LEVER"REAR CARBTUBE OUTER PIVOT BOLTWASHER SKIDWASHER DISTANCE ON PIVOT TUBEBEAR iNG JETSPRING NEEDLEBOLT BATlERY NEG LEADNUT BATTERY LEAD NEGGASKET LAMP AND LENS SEATINGFLOA T& LE VER ASS EM 8L YOVERDRIVE KIT R H SOVERDRIVE KIT L H SLENS MARKER AMBERLENS MARKER REOREFLEX ASSEMBLY REDWASHER FeR DAMPERRING RETAINING METERING NEEDLEBUSHING FOR DAMPERRING DAMPER RETAININGSCREW TOllQUE HEADGASKET SET ENGINE CONVERSIONCABLE IN~FR CHOKE CONTReL WITH KN08CABLE OUTER CHOKE CONTROLFACING p~CKAGE DRIVEN Pl~TE

RIMREFLi:X ASSEMBl YFlOAr ANC ARMSCREW WI TH 0 RING METERING NEEDLE ADJUSTINGBY PASS VALVE ASSEMBLED COMPLETEBRUSH SETSUNDRY PARTS KITTEMPERATURF COMPENSATOR ASSEMBLYCOVER ASSEMBLY

REf. NO.

10-1510-3610-8110-1610-1610-1809-1909-1909-1909-1909-1910-6910-4209-1909-1909-1909-1709-1709-1910-1809-1909-5209-3209-3209-3209-3209-3209-3209-3210-2010-2010-1409-3210-7410-7410-1410-1510-1509-1909-1909-1909-1909-5809-0410~18

1\)-1809-3410-1410-1409°-1909-1909-1910-0810-0809-1910-16

518042 519582

PART NUMBER

5195835196695197585197,,2519811519812 ..5196135198i4519815519816519817519827519B2851991252000252)00352004552:104852:>04952008052008252:108352008652D0875200B852008952009052009152M9352009452009552009652G 101521)176 .52018452018552:ll8652::Jl87520188·52H89·520 I'll52021252:>21352021452:)21552G216520244.52:>246520253'52025452025552:>256520257520258.520259520260

DESCRIPTION

GROMMET CABLE ENTRYCOVER CLUTCHSPR ING PLATEADJUSTER UNIT ASSEMBLYCOMMUTATCR END 8RACKETBUSH KITDRIVE JUt'.P RINGWASHER BUFFERARMATUREFIElD tOILBRACKET DRIVING ENDSHEll AS SEMBl YBOTTOM PLATE ASSEMBLYwASHER PLAIN CATCH GLASSVENT LEVER & SCREW ASSEMBLYRING REHIN INGCLIP SPRING LOCKING DEVICE TO HANDLESPAt I NG WASHERRETAINER CLIPBODYLENS FLASHER AMBERLENS SIDELAMP WHITERIM ASSE"8L YLENS AMB I'll.LENS FLASHER AMBERLENS STOP/TAIL REDLENS REVERSE WHITEGASKET LENS SEATINGLENS REVERSE AM8ERBULB REVERSELENS FLASHER AMBERlENS STOP TAIL REDGEAR ASSEMBLYCONTINENTAL TOURING KIT

. LEVER CAM FRONT CARBLEVER CAM REAR CARBLEVER PICK UP & LINK ASSY fRONT CARALEVER PICK UP & LINK ASSY REAR CARBSPRING RETURN CAM LEVER FRONT CARBSUCTION CHAMBER & PISTON ASSEMBLYNEDlE JETBOLT PETROL PUMP COVERWASHER Tel' COVER PETROL PUMPCOVER PETROL PUMPFILTER GAUZE PETROL PUMPRING SEALING PETROL PUMP COVERCYLINDER BLOCK ASSEMBLYCYLINDER BLOCKPIVOT AR" R HPIVOT ARI' l HSPRING TCRSION PIVOT ARM R HSpPING TCRSION PIVOT ARM L HPIN BISSEL PIVOT ARM .CRICLIP COMPRESSION SPRING RETAININGSPRING CGMpRESSIONOPERATING RODROO OPERATING R H

REF. NO.

10-1609-3409-70.

·09-7010-Q$10-0810-0810.,.0$10-;)$10-0810-0809-1709-1710-5609-1909-1910-3610-3610-3610-1310-1410-1410-1410-141:0-1510-1510-1510-1510-1510-1510-1510-1510-1010-7309-3209-3209-3209-3209-3209-3209-3209-1509-1509-1509-1509-1509-2009-0410-3610-3610-3610-36.10-3610-3010-3610-36

520260

PART NUMBER

52026152026252026352021852021952034052034152034252034352034552%0452042652H2952043252051152051252:>51352054352061552061652070652010952:l71D52G1155209575209715Z:l999

.52103052103152105752106652106752106852106952115352116952111052111654518954519054519154519'10545200054520105452020545203054520405452050545220545224545225545226545221545226545229545230

DEseR IPT ION

ROD OPERATING L HWASHER STARLOCK PIVOT PIN RETAININGPIN PIVOT OPERATING RODLEVER THROTTLE STOP & fAST IDLESPRING THROTTLE RETURNCIRCUIT eREAKER ASSEMBLYL T LEAD & GROMMETMAINSHAFT & CAM ASSEYSPRING SET ADVANCE WEIGHTLOCK WA St'ERPLUG ASSEM8LY FlOAT ChAM8ER SHlING .GEARBOX ASSYIlESS TOP COY EXTEN&HANOLEVERIUSATOP COVER ASSEMBLYGEARBOX ASSVIOVDRIVEILESS TOP COV EXTEN&HANDVACUUM CONTROL ASSYCIRCUIT BREAKER ASSYMAINSHAfT & CAM ASSYTOp COVER EXTEN & HAND LEVER ASSEMBLYSTARTER ASSY COMPLETENEEDLE METERING ADJUSTINGGASKET SET DECARBONISINGENGINE UNIT 9.0 1 HIGH COMPRESSIONENGINE UNIT 1.0 1 LOW COMPRESSIONGASKET SET DECARBONISINGSEAL KIT 8RAKE CALIPERNUT SElF LOCKINGSWITCH OvERDRIVEfUSE BOXTOP COVER EXTENION & HANG LEVER ASSEMBLYCHOKE INNER CABLE & KNOB ASSEMBLY L H SGEARBOX ASSV(lESS TOP Cev EXTEN&HANO LEVER)GEARBOX ASSYHESS TOP COV EXTEN&HANClEVER IRECGEARBOX ASSYIODRIVEILESS TOP COV EXTEN&HAND LGEARBOX ASSYILESS TOP COV EXTEN&HANDLEVERIRECDIAPHRAGM CARBOVERDRIVE KIT R H SOVERDRIVE KIT L H SSETSCREW SPOILER ATTACHOWNERS HANDBOOK USA ONLYOWNERS HANDBOOK FRENCHOWNERS HANDBOOK GERMANOPERATION TIME SCHEDULE fRENCHOPERATION TIME SCHEDULE GERMANOPER.AHON TIMES SCHEDULE ITALIANOPERATION TIMES SCHEDULE DUTCHOPERATION TlMES SCHEDULE SWEDISHOPERATION TIMES SCHEDULE DANISHOPERATION TIMES SCHEDULE SPANISHOWNERS HANDBOOK ENGLISHPASSPORT TO SERVICE fRENCHPASSPORT TO SERVICE GERMANPASSPORT TO SERVICE FLEMISHPASSPORT TO SERVICE DANISHPASSPORT TO SERVICE ITALIANPASSPORT TO SERVICE PORTUGUESEPASSPORT TO SERVICE SkEDISH

REf.NO.

10-3610-3610-3609-1909-1910-0510-05 .10-0510-05·10-0509-1909-3709-3910-7510-0510-0510-0509-4209-19u9-1909-0409-2009-2009-2009-7010-800'1-4210-1910-7510-1609-3709-3109-3109-3109-1910-7610-7310-33Ii 9-8409-8409-84 .0'1-8409-8409-84

·09-8409-84

·09-8409-84·

·09-8409-8409-8409-8409-8409-8409-8409-84

520261 545230

PART f\lIJMB ER

545232545233545235545216545237545251545253545254545255545256 .5452575452595452690545271545272054529105452n55:HZl5532525540215 %4075545175561415599805600265609715612105613355617855624035630325637695653135657565662935M515569254569313569924569945574132574133574245574437574581575&39575797575 BI3576156516157576469576656576694517064577118577119

OESCR IPT [ON

PASSPORT TO SERVICE ENGLISH/HOMEOWf\lER SERVICE STATEMENT ENGLISH/HOMEPASSPORT TO SERVICE SPANISHPASSPORT TO SERVICE NORwEGIANPASSPORT TO SERVICE FINNISHOWNERS HANDBOOK ITALIANOWNERS HANDBOOK FLEMISHWORKSHOP MANUAL ENGLISHWORKSHOP MANUAL FRENCHWORKSHOP MANUAL GERMANWORKSHOP MANUAL DUTCHWORKSHOP MANUAL ITALIANOPERATION TIMES SCHEDULE PORTUGUESEOWNERS HANDBOOK SWEDISHOPERATION TIMES SCHEDULE ENGLISH/OVERSEASOPERATION TIMES SCHEDULE FINNISHWORKSHOP MANUAL DANISHCLIP SEAL TO DOORBUTTONSTUD REAR FLOOR CARPET ATTACHMENTRIVET IMEX SECURING WINDSCREEN CAPPINGSOCKETRIVET SPRING GUIDE ATTACHMENTSCREW TRUNNION CONTROL TO WATER VAL VERIVET [MEX VENT FRAMES TO BODYRIVET VALANCE EXTENSION ATTACHMENTRIVET IMEX STUD TO B POSTlIP FASTENER TONNEAU COVERRING HOGRIVET POPPLATE BACK TRAY TO SUPPCRr RAILRIVET STUD ATTACHMENT REAR FLOOR CARPETBACK RIVET BACKLIGHT STRAP ATTACHMENTRIVET CAP lIP FASTENER TO COVERNUT RAwL CONTAINER TO HEATER VENTRIVET IMEX TONNEAU DOORBUTTON FITTED TO CARPET R H SRIVET POP HEADLAMP SURROUND ATTACHMENTVALANCE ASSEMBLY ENGINE BAY l HRIVET SETTINGS PLATE TO nASH FRONT PANEL L HSCREW CATCH TO GLASSNUT DOME CATCH TO GLASSBODY MOUNTING DETAILS PACKRIVET IMEX STUD & HOOD TO RETAINING ANGLERETA I NERRIVET REAR MOULDING ATTACHMENTWASHER PLAIN UNDER RIVET HEADlIP FASTENER BACK LIGHTSETSCREW TURN BUTTON TO TRUNK LID LeCKFIX MULTI-PRONG PRIV LOCK PIN TO ODOR SHAFTLOCK I NG CEV IC ERIVET & IIASHER FLASHER SO£KET ATTACHRIVET IMEX MOULDING ATTACHMENTSCREW SIT ANTI-RATTLE CLIPMONOLOK & BRACKET SUB ASSEMBLY L HMONOLOK & BRACKET SUB ASSEMBLV R H

545232

09-8409-8409-8409-8409-8409-8409-B409-8409-8409-8409-8409-8409-8409-8409-8409-8409-8410-3410-5910-5910-5110-5910-2910-4310-5110-3310-5410-5010-H09,..8210-4010-5910-5010-4010-1110-5010-5910-1310-3310-2910-5610-5610-2610-5310-3710-5610-6810-5310-4510-3510-3610-0910-5110-3510-6910-69

·577119

PART NUMBER

57726457726557726657726.7577294577406577407577473577611577612

, ,577712 .577713571714577715577716577717571718571119577720571721577122577123577724577725577726577127577728577129577736577737577738577739577740571141bOn,'!5600396600398603399600421700832601552601553b01S97

, 602637602638602821603344,6033826035596037'l06041326DIt14660S'}S3607610b07 b21(,07637

DESCRIPTION

TONNEAU COVER KIT WHITE R H STONNEAU COVER KIT BLACK R H STONNEAU COVER KIT WHITE L H STONNEAU COVER KIT BLACK L H SlIP FASTENER TONNEAU 'COVERMONOLOK & BRACKET ASSEMBLY L HMONOLOK & BRACKET ASSEMBLY R HSEATI NGkASHERCONNFCTING l[NKAGEASSY DOOR HANDLE L HCONNECTING LINKAGE ASSY DOOR HANDLE R HBODY COMPL pAINT& TRIMM LESS SEATS RHS SOfT TBODY COMP PAINT&TRIM WITH SEATS RHS SOFT TOPBODY PAIfI<T&TR 1M WITH SEAT&RESTRAINT RHS SOFTBODY COMI' PAINT&TRIM LESS SEATS LHS SOFT TOPBODY COMF PAINT&TRIM WITH SEATS LHS SOFT TOPBODY PAINT&TRIM WITH SEATS&RESTRAINT LHS SOF'TBODY PAINTEO&TRIMMEO LESS SEATS HARD TOP RHSBODY PAINTEO&TRIMMfO WITH SEATS HARD TOP RHSBOOY PAINT&TRIM WITH SEAT&RESTRAINT HARO TOPBODY I'AINTEO&TRIMMED LESS SEATS HARD TOP LHSBODY PAINTED&TRIHMED WITH SEATS HARD TOP LHSBODY PAINT&TRIM WITH SEAT&RESTRAINT HARD TOPBODY PAINT&TRIM LESS SEAT HARD&SOfT TOP RHSBODY PAINTED&TRIM WITH SEAT HARO&SOFT TOP RHSBOOY PAINT&TRIM WITH SEAT&RESTRAINT HARO&SOFTBODY PAINT&TRIM LESS SEAT HARO&SOFT TOP LHSBeOY PAII\T&TRTM WITH SEAT HARO&SOfTTOP LflSBODY PAINT&TRIM WITH SEAT&RESTRAINT HARD&SOFTBODY PAINT&TRIM LESS SEATS SOFT TOP LHS USABODY PAINT&TRIM WITH SEAT&RESTRAINT SOFT TOPBODY PAINT&TRIM LESS SEAT HARD TOP LHS USABODY PAINT&TRIM WITH SEAT&RESTRAINT HARO TOPBODY PAINT&TRIM LESS SEAT HARO&SOFTTOP LHS UBODY PATNT&TRIM WITH SEAT&RESTRAINT HARO&SOFTGllOMMETGROMMET SPEEOO CABLE DASH SHELFPLUG SILL PANELl1/2 HOLEIPAINT DRAINAGE HOLESPLUG MA IN FLOORIl HDlHPAINT DRA'INAGE PIOGSPLUG FLOOR HDLE1l3/16 HOLEIPAINT DRAINAGE HOlPIN HANDLE ATTACHMENT 'ROD BATTERY fIXINGANGLE BA1TERY RETAININGPLATE RETAINING STEERING COLUMNHOSE OEMISTER SHORT (DRIVERS SIOEIHOSE OEMISTER LONG IPASSENGERSSIOEISEAL CHECK ARMSPRING GUIDE CHECK AR~

SPRING REGULATOR ESCUTCHEONCUP WIRINGPLUG RUBeER IS/16 I DASH SHELF PANELTUBING T PIECE TO JETSTUBING PLUNGER TO T PIECESLEEVE TERMINALPLATE TAPPED HINGEARACKET MOUNTING DASH FRONTPLATE BRACKET MOUNTING DASH FRONT

REF. NO.

la-5010-5010-5010-5010""5010-7010-7010-3610-3610-3610-2310-2310-2310-2410-2310-2310-2410-2310-2310-21t10-2310-2310-21t10-2310-2310-2410-2310-2310-241072310-2310-2310-2410-2309-7610-1810-1610-1210-1210-3710-2010-2010-4110-4310-4310-3410-2910-311.0'"'2710-1210-1110-1110-1310-2910-2910-29

571264 601031

612850

PA.RT iIlUMB ER

6076636076646071116C77456<;7823

. 6078246078676078696079026081396081855>08-222608356508383608462608511(,1)851660952060856360860460864360875660881560881760912360917260918460918560963960993161(1)426l:l5206D6246H16756110116110126U177611368611428611444b 116656117936118226119386123016124736124755>12527612528612577612601612616612617612703612806612850

DESCRIPTION

BONNET CATCH ASSEMBLYPLATE CATCH BONNET LOCK DASH SIDE FRONT LOWERPlATE BACK WHEHARCH TO BON RElNFOR TO WHEELACLIP LOCAlING llSt!NG RAILPIN OOOR HINGEHINGE DOOR ASS YSTUD RETAINER REGULATOR TO CHANNEL8RACKET ASSY ANCHOR REAR BONNET HINGE TUBEWASHER LEATHER REGULATOR TO CHANNELINSULATOR SLIP RINGCLAMP SUPPORT 8RACKET STRG COLUMNtLOWERIFELT STRIP SUPPORT BRKT 1800YlCABLE ASSY SLIP RINGPLATE RETAIN GEARBOX COV TO DASHSIOE FRONT&FLSLIP RING & INSULATOR ASSEMBLYCLIP TRI~ PAD TO DOORCLIP LONG TRIM PAD TOP EDGE TO DOORCLIP'SEAL ATTACHMENTSEAL GEARBOX COVER REARCLIP SECuRING WAIST WEATHERSTRIPPACK I NG SPONGESEAL GEARBOX COVER TOP&SIOESPLATE FI~ING RADIOCLIP SQUAB TENSIONER TO CROSS BRACETRUNNION CONTROL TO WATER VALVECONH INER WATERPLUG RUBSERPLUG RUBBERSPRING STEERING COLUMN CLAMPPLATE TAPPING CATCH PLATE TO DASH SIDEWASHER SECURING HINGE TO A POSTCLIP TRIM SQUAB COVER TO CROSS BRACESTUD FRONT FLOOR CARPET ATTACHRUBBER SEALING BONNETLABEL INSTRUCTION FLASHER SWITCH LHSLABEL INSTRUCTION FLASHER SWITCH RHSWASHER RUBBER GEAR LEVERCLAMP STRG COLUMN UPPER HALFVACUUM S.ITCH .SEAL TRUNK LI 0REINFORCEMENT DASH SHELFCLIP CABLE HORN LEADS TO RADIATOR CRADLEPAD RUBBER FOOTRESTPLATE COV MAIN FLOOR PROvlD ACCESS TO DDRIVEPLUG SEAl PANtl/8 HOLEIPAINT DRAINAGE HOLESSTAY ASSEMBLY TRUNK LIDSCREW SHOULDERED STAY TO BODY&TRUNK LIDBRACKET ~OUNTING DASH FRONT OUTER L HBRACKET MOUNTING DASH FRONT OUTER R HANGLE SILL REINFORCEMENTT PIECfBRACKET SONNET LOCATIONPLATE BONNET PEG LOCATINGCLIP LIGHTING CABLES TO CHASSISWEATHERSTRIP WAISTPLATE SUPPORT PARCEL TRAY

607663

REF.NO.

10-3210-3210-3210-5510-3410-3410-3510-3210-3510-4110-'4110-41lQ-4110-27lu-4110-3710-3710-3210-2710-3410-3210-2110-2710-6it10-4310-1110-1210-7210-4110-3210-34IO-bO10- 5-910-3210-0910-0909-4210-4109-8210-4510-2910-2110-2710-1410-7210-4510-4510-2710-2710':'2710-1110-2910-2910-2110-3410-29

616034

PART NUMBER

61296261297061291661298161302461302 561304561304961305161315561j169613118613186613239613326

- 613350613351613 362613 3 78613417613466613467613474613478613493613519613607b 13 646613650613656613659613666613 685613686613 68761375161376661381261388661394161396261396361400661412561t+l26614926615699615106615701615810615811615837615980615984616011616034

OESCR IPT ION

PEG BONNET LOCATIONTUBE DRAIN BATTERY BOXPLUG RUBeER WINDSCREEN CAPPINGGUSSET PEDALS DASH SHELF l H R H SCHECK AR~ ASSY DOORGROMMET CRAIN TUBELINK ASSEMBLY UPPER BONNET STAYBOLT STOP SECURING SPACING BLDCK TO GUIDE eLCROO BATTERY fIXINGRUBBER BATTERY SHELFCLIP SECURING SEALING STRIPBLOCK MOUNTING BODY TO MTG BRACKET DASH FRONTASH TRAY IN FACIA TOP PANELRIVET CHECK ARM TO BODYBLOCK SPACINGBRACKET ASSY CHECK STRAP L HBRACKET ASSY CHECK STRAP R HFOOTREST GfBOX COVERDOOR GLASS STOP BRACKET ASSEMBLYSTRIP GLAZINGPAD SEALING tRUBBERI STEERING COLUMNFELT STRIP CASING BOARD PETROL TANK REARWASHER CATCH PLATEBRACKET SUPPORT REAR EXHAUST PIPEBRACKET MTG WATER VALVE & IGNITION COILBRACKET SUPPORT PETROL TANK CASINGRING RETAINING GROMMET 'SEAL INLEr & OUTLET PIPESJET MOUNTING ASSYREINFORCEMENT ASSY PETROL TANK SUPPORT l HREINFORCEMENT ASSY PETROL lANK suppeRT R HSEAL REAR FRONT WHEELARCH TO DASHGUSSET PEDALS DASH SHELF R H R H,SGUSSET ASSEMBLY BATTERY BOX DASH SHELF L HGUSSET ASSEM6LY BATTERY BOX DASH SHELF·R HLINK ASSEMBLY LOWER BONNET STAYCLIP UPPER REAR WING fINISHER ATTACHMENTCOVER'REAR SPRING ACCESSCLIP UPPER REAR WING fINISHER ATTACHMENTWASHER a HEATER TO DASH SHELF PANELMOULDING BACKLIGHTFINISHER BACKLIGHTBUSH FR ICTIONSEAL HEATER BLOWERCLIP CONTAINERWOOOSCREwWASHER PLATE VALANCE TO REAR MTG BKT ON OASHBRACKET FIXING REARCLIP BRAK~ & PETROL PIPESREINFORCEMENT BUMPER ~TTACHMENT LO~ER REARCLIP OVERDRIVE HARNESS TO BULKHEAD flANGECLIP CABLE SENSOR LEAD TO SEATPLATE ASSY REINFORCEMENT SAFETY HARNESS FIXINWASHER ASSY REINFORCEMENl SAfETY HARNESSTUBE FLEXIBLE AIR CLEANERTRUNNION CABLE ATTACH TO CONTROL LEVERS

612962

REf.NO.

10-3110-2910-5110-2910-3410-2910-3210-3410-2010-2010-34-lO-2{,10-3910-3410-3410-2910-2910-2110-3410-3410-4110-6010-3210-2S10-4310-2809-4210-4210-1110-2810-2810-3210-2910-2910-2910-3210-5110-2810-5110-4210-5610-561,0-3010-4210-1110-3910-3310-29

, 09-6010-2810-1510-6110-2110-2809-3010-42

L H SL H STO B POST

PART NUM8ER

61(,048616206016627616925617078617296618120618111018178618274618275618486513481613505618511'61817561909961910061938361938461943261950961985061985962040362'54162G150620952621101

,621112621314621438621458621465621510621685621686621705621706(,21701621714521721621751621158621768621776621811621967621968622150622220622222622223622224622228622229

DESCR IPT ION

WASHER PVCFLAP DRAIN AIR BOXSEAL INLET & OUTLET PIPESGROMMET FITTED IN CAPPAD SOUND DEADENING SELF ADHESIVESTUD TONNEAU COVER ATTACHMENTVALVE NON-RETURN BETWEEN PUMP& T PIECESAIL EYELETRING SAIL EYELETRETAINER LOCK STRIKER L'HRETAINER LOCK STRIKER R HATTAGHME'NT PLATE L H FACIA FACINGSATTACHMENT PLATE R H FACIA FACINGSSTUD P(ATECUP DID HARNESSCLIP TRI~ SQUAB COVER TO TORSION BARPLATE TAPPEO LOCK STRIKER L HPLATE TAPPED LOCK STRIKER R HSTRIKER 8LOCK TRUNK LID LOCKSLEEVE STRIKER 8LOCKREINFORCEMENT DASH SHELF CENTREGUIOE BLOCK & STIFFENER CHANNEL ASSEMBLYCLAM? STEERING COLUMN UPPER HALFCLIP HOOD LINKAGE COVERDOOR SEAL A POSTPLATE TAPPED STEER~NG COLUMN SUPPORTSCREw GRUB KNOBCLIP REVERSE LIGHT LEAF TO DASH FRONT PANELPAD MOUNTING SAFETY HARNI:SS FIXINGPLATE REINFORCE~ENT ASSEI'BLY SAFETY HARNESSWASHER WAVED RUNNING LOOP TO WHEElARCHSUPPORT WHEEL ARCH TO REAR DECKKNOB SAFETY CATCHRIVET LINK NO 1 TO HEADER RAILSPACERHOOK RETAINING STRAPBRACKET RELAY SUPPORT L H SRETAINER INTERIOR MIRRORGUSSET PEOALS DASH SHELF L HGUSSET PEDALS DASH SHELF R HSHIM PACKING STRIKER DOVETAI,LPAD FELT PETROL TANK FRONTHANDLEWASHER WAVEDKNOB HANDLECLIP KNOB TO SHAFTWINDOW REGULATOR HANDLELABEL INSTRUCTION LIGHTING SWITCH R H SLABEL INSTRUCTION LIGHTING SWITCH L H SCLIP HEATER HOSE FOOT LEVER VENTBRACKET ASSEMBLY HEATER vENT CONTROLPLATE SWITCH RETAININGWASHER PLATESPACER THICK CONTROL LEVER TO FACIA 8RKTKNOB ASSEMBLY WATER VALVE LEVERKNOB ASSY VENTILATOR CONTROL LEVER

&16048

REF. NO.

10-lB10-4310-4209-8210-3410-5010-1110-5010-5010-3010-3010-3910-3910-3910-7910-6410-3010-3010-4510-4510-2910-3410-4110-5410-3110-4110-4210-1910'"'2610-2810-7010-2810-6810-5210-1810-6110-2910-3810-2910-2910-3509-7610-5410-5410-3710-6810-3710-0910-0910-2910-3910-3910-'3910-1110-4210-42

622229

624741t

PART NUMBER

b 22 230622235622 2361>222.37622443I> 224456226826228126228.68623200623312623468623489623796623B436241556241936242766243606243n624397624406I> 244196245081>2.. 5096245451>24546(, 21>5571>24558624564624569b 245BO624583624584624586624590624591624593624599b2"'6006246016246071>24608

. 624618624634624612624687624691624701b2lt711624120624725624729624730&24133624744

OESCR IPT ION

PLATE SwiTCH RETAINER HAlARD LIGHTSPACER THIN LEVER CONTROL TO FACIA BRACKETL~VER CONTROL VENTILATOR&HEATER MOTORLEVER CONTROL WATER VALVEBEZELPROTECTION PADNUT SPACERCAPPING ASSEMBLY OEMISTER OUTLETBOLT DOMED HARD TOP TO HEADER RAILSPRING TENSION lOCKING LEVERCUP BRAKE PIPE ..TIE BAR STEER COL CLAMPIUPPERITO FACIA SUP BKTIE BAR STEER COL CLAMPlUPPER1TO FACiA SUP 6KBRACKET ASSEMBLY RAOIUS ARM MOUNTINGESCUTCHEON HANDLECLIP BRAKE & FUEL PIPECABLE ASSY HEATER SCREENLABEL PULL 800STPIN LOCKING ASSEMBLYESCUTCHFON (HOOD CLOSUREIREINFORCEMENT ASSEMBLY BUMPER SUPPORT REARBRACKET PIVOT HANDBRAKEANGLE ATTACHMENT FRONT VALANCE OUTERBUSH BONNET HINGE TUBESPACER BONNET FULCRUM PINHANDLE ASSEMBLY HOOD CLOSURE HOODSTICKS L HHANDLF ASSEMBLY HOOD CLOSURE HOODSTICKS R HSIDE FRONT WING l HSIDE rRONT wING R HBRACKET SUPPORT PETROL TANK CASING BOARDBOLT DOME HEAD LINK N04 TO LINKS NO 2 3 & 5BUSH SHOULDERED ON BOLTWASHER UNDER BOLT HEADNUT DOME ON BOLTLINK NO 2BRACKET JlTTACHMENT FRONT VALANCE OUTERBRACKET GENTl< EGR ILL E SUPPORTBRACKET ASSEMBLY OUTER GRILLE SUPPORTLlNK NO 5 L HLINK NO 5 R HBRACKET ASSeMBLY CENTRE VALANCE SUPPORTWIRE ATTACH BOTTOM INTERMEDIATE STRAP INNERLHWIRE ATTACH BOTTOM INTERMEDIATE STRAP INNERRHSPRING SAFETY CATCHBAR DOOR PULL INSIDEBRACKET MOUNTING COVER REAR LAMPSCABLE ASSEMBLY WATER VALVEFINISHER TRIM WINDSCREEN UPPERFINISHER TRIM wINDSCREEN SIDE L HFINISHER TRIM WINDSCREEN SloeTIE BAR HARD TOP TO BODY SIDEWIRE ATTACH BOTTOM INTERMEDIATE STRAP OUTERWASHER SEATING ESCUTCHEON TRUNK LID LOCKNAMEPLATE ASSEMBLY SPITFIRE IV BONNETNAMEPLATE ASSEMBLY SPITFIRE IV REAR WINGBRACKET FRONT NUMBER PLATE

622230

10-3910-4210-4210-4210-1810-5310-1810-4310-57 .10-6809-1410-4110-4110-2110-3709-7410-4210-4210-5410-5410-2810-2710-3310-3110-32l(j-5410-5410-3110-3110-3010-5210-5210-5210-5210-5210-3310-3310:--3310-5210-5210-3310-6410-b410-6810-3510-7510.,.4210-3810-3810-3810-5110-6410-4510-3110-30'10-51

OUTER L HOUTER R HINNER l HINNER R H

624746

.. OESCR IPTION

10-5610-5610-%10-5110-5110-56la-5710-5410-5710-6810-56la-5610-5610-68' .10-6810-5710-5710-5610-6510-6510-0510-6510-6910-69

. 10-6910-6210-3110-3110-3010-3010-6610-6610-6610-6110-5309-4210-3910-1410-4210-5110-1810-6B10-6810-1610-6110-6110-2810-1909-5810-5110-4809-57H)-5410-5410-1910-19

627740

l HR H

DECK REAROECK FRONTDECK FRONT

f

SEAL HARD TOP TO REARSEAL HARD TOP TO REARSEAL HARD TOP TO REARFINISHER REAR DECKCATCH ASSEMBLY REAR QUARTER VERT l HCATCH ASSEMBlV REAR QUARTER VENT R HBOLT HEX DOMED TIE BAR TO BODV SIDEeOLT OOMED HARD TOP TO REAR DECKTUBE DISTANCE ASSY HARD TOP TO HEADER RAILBUFFER RUBBER .WEATHERSTRIP ROOF TO OECKBRACKET BODY REAR QUARTER VE~T R HBRACKET eODY REAR QUARTFR VENT L HLEVER LOCKING L HLEVER LOCKING R HTIE BAR rARD TOP TO BODY SIDE l HTIE BAR rARD TOP TO BODY SIDE R HSEAL REAR DECK INNERBOARD ASSEMBLY SQUAB SIDEBOARD ASSEMBLY SQUAB SItE80ARD ASSEMBLV SQUAB SIDEBOARD ASSEMBLV SQUAB SIDEBRACKET TUNNEL BUCKLE l H8RACKET TUNNEL BUCKLE R HCOVER WHEELARCH ANCHORAGEPLUG HEAD RESTRAINT APERTURENAMEPLATE ASSEMBLY (SPITfiRE 15001 BONNETINSERT NAMEPLATE BONNET (SPITfiRE 1500)NAMEPLATE ASSEMBLY REAR WING (SPITFIRE 1500INSERT NAMEPLAT_E SPITFIRE 1500 REAR IiINGfINISHER HEAD RESTRAINT BLACKFINISHER HEAD RESTRAINT CHESTNUTFINISHER HEAD RESTRAINT SHADOW BLUESTRAP ASSEMBLV HOOD STOWAGE COVER NEW TANFINISHER lIP fASTENERNUTCUP WASHERWASHER SPECIAL SIDE MARKER ATTACHCABLE ASSEMBLY WATER VALVEBRACKET fRONT NUMBER PLATE USAKNOBSLEEVE CATCH LEVER ENDSPRING TENSION CATCH LEVERBADGE ASSY (TRIUMPH)STRAP ASSEMBLY RETAINING OUTER (BLACK)STRAP ASSEMBLY RETAINING CENTRE (BLACKIBRACKET ASSEMBLY SPARE WHEEL MOUNTINGRRACKET IGNITION SWITCH ILLUMINATIONCLIP PROTECTION STEERING LOCKCUP UPPER .\ LOWER MOULDING ATTACHMENTSINSERT NAMEPLATE TRIUMPHBADGE WIRE WHEEL HUB FINISHERCOVER wITH HOOK HOOD TO B POST&SAFE HARN STOwCAP HOOD TO B POST ATTACHMENTSWITCH IGNITION WARNING A POSTSWITCH ILLUMINATION STEERING LOCK R H S

PART NUMBER

624746624747624- 74862'tBOl62481162'tB12624-81762481862.. 825624-82862'tB31624860624861624869624B70624873621+874624876624887624888624893621,.89462'tB9562'0896

, 6248976251396251866251876251886251896251''1625193625197625293625380625536625549625580625687625886625 ~66

62637Q0263736268596270216270316271960273186273401:>27 36202756462757962764862764'162773362174;)

PART NUMBER

62777562780162190062794562609762837562840262840962951862958463'068/> ::l007963)27863B211>30331630451630512I> 305136305356305786306246306426306616306636306646306696307666301616309326%93363096163098163::19<l4630995to 3101 B631190631315631378631403631413631431to 31432631514631575

.631592631122631711631782632020632030632039632040632061632063632067632089

OESCR II' TION

eOLT WHEELARCH ANCHORAGESPACER W~EELARCH BELT ANCHORAGEMOULDING PROTECTION TRUNK LIDWASHER BUCKLE TO BRACKETSPRING HU8 TRIM DISC WHEELS

-PLATE SUPPORT SPEEDO TRIP CONTROLSUPPORT eRKT ASSY STEERING COLUMN LOWERFELT STRIP SUPPORT BRACKET (CLAMI'ISPACER WhEELARCH ANCHORAGEWEATHERSTRIP WINDSCREEN TO HEADER RAILFINISHER ASSEMBlV HUB WIRE WHEELSPIN ADJUSTMENTANGLE SUPPORT PARCEL TRAYCARPET DASH SIDE BLACK L HCARPET OASH SIDE BLACK R HSTRAP RETAINER HEADER RAILBRKT ASSY INNER FIT TWEEN DEMIST CAP&FACIA CRBRKT ASSY OUTER FIT TWEEN OEMIST CAP&FACIA CRBRACKET RHEOSTAT SWITCHSUPPORT ASSV PROTECTION MOULDING TRUNK LIDCENTRE HUB FINISHER·CAPPING B/LIGHT FINISHERGROMMET PIPE SUPPORT BRACKETBOLT FLOOR ANCHORAGEBOLT BUCKLE TO BRACKETSPACER HOOD TO 8 POST ATTACH~iENT

SiR,Ap. BACKL lGHT RETAINERSHIM HINGE TO TRUNK LIDBAR .MOUNlI NG L HBAR, MOUN TI HG R HWEATHER STRIP HEADER RAILINTERIOR ~IRROR ASSYRETAINER INTERIOR MIRRORBASE INTERIOR MIRRORPLUG BLANKING REAR BUMPER HOLESWASHER RUBBER BUMPER ATTACHMENTFINISHER JOINT WINDSCREENNAMEPLATE BONNET (GER,MANYIMEDALLION SPORTS CAR AWARDFINISHER HUB WIRE WHEELCATCH LEVER L HCATCH LEVER R HHOOK SEAT BELT STOWAGE L HHOOK SEAT BELT STOwAGE R HBRACKET ASSY HANDBRAKE RELAY MOUNTINGWASHER INSULATION BUCKLEPAD PROTECTIONFINISHER lIP FASTENER BACKLIGHTSTRIP PROTECTION BONNETCLIP BONNET PROTECTION STRIPRETAINER STRAP H~ADER RAILSTRAP BACKLIGHT RETAINERSTRAP ASSEMBLY HOOD STOWAGE COVER BLACKSTRAP ASSEMBLY HOOD STOWAGE COVER CHESTNUTSTRAP ASSEMBLY HOOD STOWAGE COVER SHADOW BLUEMIRROR ASSEMBLY COMPLETE

627775

REF. NO.

10-6910-7010-5110-69Q9-5710-4110-4110-4110-6910-5409-5710-3510-4010-5910-5910-5310-5010-5010 3910-5109-5710-5609-1 a10-6910-6910-5410-5310-4510-3810-3810-%10-3B10-3810-3810-1610-4610-3810-3110-3909-5710-6810-6810-7010-7010-2710-7010-5310-5310-3210-3210-5310-5310-6110-6110-6110-38

632089

PART NUMB Ell.

6320916321046321516321536321576321616321636321671>32181632187632191632193632197632200632201632234032244632254032271(,32300032511632521f> 3Z804(,32806(, 32 987632994633053633093633103(,335906342&363'> 72363472863'>93105;)2477057897061597061607062887("628970042270642370078170078210078<)70679C7')6 B01706843106844706'H970&915707315707316707349707931108479

DESCRIPTION

HEAD ASSEMBLY MIRRORFOAM RIC FRONT ODORTRIM PAD REAR QUARTER 1 H BLACKTRIM PAO REAR QUARTER L H CHESTNUT,TRIM PAD REAR QUARTER L H SHAOOw BLUETRIM PAD REAR QUARTER R H BLACKTRIM PAC REAR QUARTER R H CHESTNUTTRIM PAD REAR QUARTE~ R H SHADOW BLUECOIIERB POST L H BLACKCOVER B POST L H SHADOW eLUECOliER B POST R Ii BLACKCOliER B POST R H CHESTNUTCOVER B POST R H SHADOW BLUEWATER CURTAIN RIC FRONT DOORCARPET ASSEMBLY REAR SEAT PANCOliER ASSEMBLY REAR SHELF CENTRE HARD TOPCOVER B POST HARD TOP L HCOVER B POST HARD TOP R HGROMMET HANDBRAKE REAR FLOOR CARPETPLINTH ASSEMBLY NAMEPLATE REAR BUMPERCOVER A POST UPPER L HCOVER A POST UPPER R HPLATE ASSEMBLY LOCATION AUTO REEL L HPLATE ASSEMBLY LOCATION AUTO REEL R HPLATE HAZARa LIGHT RETAINING 18 A 0 RISTRIP PROTECTIONFINISHER HEAD RETRAINT NEW TANTRIM PAD REAR QUARTER L H NEW TANTRIM PAD REAR QUARTER R H NEW TANCENTRE WHEEL TRIM8 POST COVER L H INEW TANIB POST COliER R H {NEW TANIPLATE SERRATED REINFORCEMENT SUPPORTEDGE FINISHER REAR IMPACT REINFORCEMENT UPPERGROMMET PETROL FILLER CAPGROMMET HANDSRAKEREINFORCEMENT ASSY BODY MOUNTING L HREINFORCEMENT ASSEMBLY BODY MOUNTING R HPANEL A POST OUTER LOwER L HPANEL A POST OUTER LOWER R ~

PANEL FILLER SILL FRONT L HPANEL FILLER SILL FRONT R HCHANNEL GLASS ASSEMBLY FRONT L HCHANNEL GLASS ASSEMBLY FRONT R HCHANNEL ASSEMBLY BOTTOM WINDOw REGULATOR 1 HCHANNEL ASSEMBLY BOTTOM wINDOW REGULATOR R HPA~EL ASSEMBLY COVER SPARE WHEEL80ARO RADIATOR AIR DEFLECTOR L HBOARD RACIATOR AIR DEFLECTOR R HGROMMET FITTED IN FLOORPAD SOUNe INSULATION REAR FLOORHEElMAT L H L H SHEElMAT R H R H SCOVER GEARAQX ASSYDOOR SEAL NEOPRENEESCUTCHEON FLASHER & LIGHTING SWITCH

632091

REF. NO.

10-3B10-3510-6010-6010-6010-6010-6010-6010-6010-6010-6010'""6010-6010-3510-6010-5510-5510-551,0-5910-4810-5910-5910-7010-7010-3910..,4510-6610';'6010-6009-5710-6010-6010 4810-2809-7610-2710-2810-2810-2910-2910-2910':"2910-3410-3410-3,410-3410-4509-8209-8209-4210-2810-5910-5910-2710-3710-41

708479

PART NUMBER

7093877093887096917098427098437v) 2907108207125367129137 HO"367130377130387134917l.3499713 5017135117135197135217135317144347l499Q7155257155267155b7715b73715674715bCl37156957156'n7157017157021157067158057158217158427158637158647158677158687l51l69715870715871715872715873715874715885115886715889715'1827159831\601171602571b02b716032116033711> 143

DESCRIPTION

CHANNEL GLASS ASSY REAR L HCHANNEL GLASS ASSY REAR R HBRACKET SUPPORT PARCEL TRAYCOVER-PLATE RADIO APERTUREPLATE MOUNTING RADIOTRUNK LI C LDC K ASS YGROMMET GEAR LEVER OVERDRIVEGROMMET & MILL BOARD ASSEMBLY HANDBRAKEKNOBRETAINER CENTRE HEADER RAIL SEALING STRIPRETAINER OUTER HEADER RAIL SEALING STRIP L HRETAINER OUTER HEADER RAIL SEALING STRIP R HBUTTON BLACK8UTTON WHITESOCKET HACKSTUD BLACKSTUD WHI TERIVETPIVET BUCKNOZZLE DEMISTER ASSYSUPPORT ASSY BOTTOM PIVOT TRUNK LID STAYHINGE ASSEMBLY TRUNK LID L HHINGE ASSEMBLY TRUNK LID R HBRACKET SUPPORT INNER PETROL TANKBRACKET ASSY PETROL TANK SUPPORT OUTER L HBRACKET ASSY PETROL TANK SUPPORT OUTER R HFINISHER REAR WING UPPER~OULOING ICHROMEI REAR END UPPERMOULDI~G ICHROMEI REAR END LOWERSUPPORT REAR BUMPER L HSUPPORT REAR BUMPER R HSUPPORT REAR BUMPER SIDEBRAC~ET ASSEMBLY BONNET HINGE PIVOTfINISHER LOwER REAR WING JOINTANGLE RETAINING HOOD TO REAR DECKFRONTAL GRILLE L HFRONTAL GR I LL E R HPLATE MOUNTING ASSY HOOD FRAME TO BODY L HPLATE MOUNTING ASSY HOOD fRAME TO BODY R HLINK NO :3 l HLINK NO :3 R HLINK NO 1 L HLINK NO 7 R HLINK NO 1 L HLINK "10 1 R HPANEL ASSY fRONT OUTER REAR wHEELARCH L HPANEL ASSY FRONT OUTER REAR WHEELARCH R HFRONT VALANCE CENTRE ASSEMBLY ,BRACKET ROLLER GUIDE DASH SIDE L H8RACKET ROLLER GUIDE DASH SIDE R HMOULDING ODOR PULLBRACKET HARD TOP TO BODY SIDE L HBRACKET HARD TOP TO BODY SIDE R HPOUUt TOCLPOUCH TOCL (V S A ONLYISAFETY CATCH ASSEMBLY L H '

709387

REF. NO.

10-3410-3410-3910""4010-4010-4509-4210-27 "10-1810-5410-5410-5410-5010-5010-5010-5010-5010-6010-0;410-4310-3010-4510-4510-3010-2810-2810-5110-5110-5110-4710-4710-4710-3210-3010-5310-3310-3310-5210-5210-5210-5210-5210-5210-5210-5210-2810-2810-3310-2910-2910-3510-5710-5709-8309-8310-68

716143

PART NUMB ER DESCRIPTION

10-oB1(\;'2910-2909-5710-2810-5610-5610-1010-4110-4110-6810-4510-4510:"1610-5910-5910-5910-5910-2810-2809-1609-5810-6910-6910-7010-3110-3210-3510-4510-3510-6610-1110-53H)-5310-43HI-51

'10-5111)- 3610-5510-5510-5509-7610-3910-3110-2810-2810-3309-8309-8310-6610-3710-3710-3410-3410-3710-37

L HR H(GERMANY I

INNER ASSEMBLYINNER ASSEMBLYVALANCE CORNERAl

SAFETY CATCH ASSEMBLY R HRETAINER ASSY TAPPED PLATE A POST L HRETAINER ASSY TAPPED PLATE A POST R HWHEEL TRIM (DISC WHEELSIVALANCE ASSEMBLY REAR UPPERSEU DOOR GLASS L HSEAL DOOR GLASS R HTUBING W~EELBOX TO WHEELBOXTIE BAR (JUTEP, STEERING COLUMN'TO FACIA R H STIE BAR OUTER STEERING COLUMN TO FACIA L H SHANDLE OPERATING ADJUSTING BACK SEATCOVER SPARE WHEEL ASSY SEWN (DISC WHEELSIcrVER SPARE WHEEL ASSY SEWN (WIRE WHEELSIREAR NUMBER i'lL ATE LAMP & BADGE ASSYCA~PET FRONT FLOOR BLACK L H R H SCARPET FQONT FLOOR BLACK R H R H SCARPET FRONT FLOOR BLACK R H L H SCARPET FRONT FLOOR BLACK L H L H SPANEL WHEELARCH INNER ASSEMBLY L HPANEL WHEELARCH INNER ASSEMBLY R HSEAL VENTED PETROL-FILLER CAPCOVER pRCTECTION STEERING LOCKSAFETY HARNESS KITSAFETY BELT ASSEMBLYSAFETY BELT IAUTO REELI AUDIBLE WARNING TYPEHOUSE BADGE FRONT WINGSUPPORT PONNET REARSTRIKER DOVETAIL ASSEMBLY R HB\JT1'1N TURN TRUNK LID LOCKSTRIKER COVETAIL ASSEMBLY L HPAD ASSY HEAD RESTRAINTCONTAINER WATEROUARTERLIGHT HOOD L HQUARTERLIGHT HOOD R HVALVE WATER ASSEMBLYMOULDING PROTECTION REAR L HMOULDING PROTECTION REAR R HBRACKET CLAMPING OUTSIDE DOOR HANDLELISTING RAIL NO 1 HEADLININGLISTING RAIL NO 2 HEADLININGLISTING RAIL NO Z HEADLININGCAP PETReL FILLER ASSEMBLYFACIA PA~EL ASSEMBLY IL H SI USAHOUSE BArGEPANF.l WHEEL AR CHPANEL WHEElARCHEXTENS ION FRONTTOOL POUCH (U STOOL POUCHFRAME ASSEMBLY HEAO RESTRAINTPAD ASSY DOOR TRIM NEW TAN L HPAD ASSY DOOR TRIM NEW TAN R HEXTERIOR MIRROR (DRIVERS OOORIDRUM ASSEMBLY EXTERIOR MIRRORPAD ASSY DOOR TRIM BLACK L HPAD ASSY ODOR TRIM CHESTNUT L H

71614471614971&1 ';l'HOlMH61A2710183716184716B037169667169677171057176017176117180287180617180n71"'39171810171'\7167187171181387188137J.9912719913719947721 '>93722631722671722675727.71>072293772329772334972335072402172402117240297241927250B47251)857;>50'3672511772543172552572556372551>4725&7072579472579572597172609372'>103726385726387726451726453

716144 726453

PART NU"'B ER

721>457121>4611264631264&712&46112649112652472653412">51.412& 5&1126511726<;8112063172&633126637726641726643726647721>8707274517274'i3721457

·12746172746172146772750172750372150712751112751312751772758112759172765172765312165772767372863172864172953012962312963312910372<l713730';0173053073:)9137309238(l3762806634806635806638806b398061('\7807030807104

OESCR IPT ION

PAD ASSV DOOR TRIM SHADOW BLUE L HPAO ASSV DOOR TRIM BLACK R HPAD ASSV DOOR TRIM CHESTNUT R HPAD ASSY DOOR TRIM SHADOW BLUE R HTRIM PAD ASSV G/BOX COVER SIDE l HTRIM PAD ASSY G/BOX COVER SIDE R HCOVER ASSV REAR SHELF SIDE L H HARD TOPCOVER AS$Y REAR SHELF SIDE R H HARD TOPHEADLINING ASSY BEIGEGEARBOX CARPET ASSEM8lY R H SGEARBOX CARPET ASSEM8LY L H SGAUNTLET ASSEMBLY GEARBOX COVER CARPETCOVER REAR WHFELARCH BLACK L HCOVER REAR WHEELARCH CHESTNUT L HCOVER REAR WHEELARCH SHADOW BLUE L HCOVER REAR WHEELARCH BLACK R HCOVER REAR WHEELARCH CHESTNUT R HCOVER REAR WHEELARCH SHADOW BLUE R HESCUTCHECN ASSEMBLY HEATER CONTROLCOVER CUSHION BLACK L H

. COVER CUSHION CHESTNUT L HCOVER CUSHION SHADOW BLUE L HCOVER CUSHION BLACK R HCOVER CUSHION CHESTNUT R HCOVER CUSHION SHADOW BLUE R HSQUAB COVER ASSEMBLY BLACK L HSQUAB COVER ASSEMBLV CHESTNUT L HSQUAB COVER ASSEMBLY SHADOW BLUE L HSQUAB COVER ASSEMBLY BLACK R HSQUAB COVER ASSEMBLY CHESTNUT R HSQUA~ COVER ASSEMBLY SHADOW BLUE R HTRIM DOOR WAIST RAIL l HTRIM DOOR WAIST RAIL R HCOVER HEAD RESTRAINT BLACKCOVER HEAD RESTRAINT CHESTNUTCOVER HEAD RESTRAINT SHADOW BLUECOVER HEAD RESTRAINT NEW TANSUPPORT PARCEL TRAV & CRASH PAD ASSY l HSUPPORT PARCEL TRAV & CRASH PAD ASSY R HLOCK TRUNK LID (KEV OPERATEDISQUAB COVER ASSEMBLY NEW TAN L HSQUAB COVER ASSEMBLV NEw TAN R HCOVER CUSHION NEW TAN L HCOVER CUSHION NEW TAN R HPLATE SUPPT ASSY FRONT IMPACT SHOCK ABSORBERBRKT ASSY SUPPT REAR IMPACT SHOCK ABSORBERREAR HHEELARCH COVER L H (NEW TANIREAR WHEELARCH COVER R H (NEW TAN)PAD ASSY SOUND INSULATIONPANEL SILL REINFOR REAR lHIFIT TWEEN INN&OUTPANEL SILL REINEOR REAR INNER~OUTER SILL FANEPANEL SILL INNER L HPA~EL SILL INNER R HBATTERY BOX ASSEMBLY R H SBATTERY BOX ASSEMBLY L H SCROSS MEMBER ASSEMBLY HEELBOARD

726457

REF.NQ.

10-3110-3710-37

. 10-3710-5910-5910-5510-5510-5510-5910-5910-5910-bO10-6010-bO10-6010-bO10-bO10-3910-6710-67

10-b110-6110-6710-b710-6510-6510-6510-6510-6510-6510-3710-3110-6610-6610-6610-6610-4010-4010-4510-6510-65

. 10-6110-1>710-3210-4810-6010-6~

10-2710-2110-2110-2110-2710-2910-2910-27

807104

PART NUMBER

BO'H1680974080978580')786812<)81912 <)9181327\flB2fll813365813366813 745813 746813153813 75ft813893813 8941113 942813Q44':l13945813<)4681H3381473481ftf\2811150108150268150418150428151358151368151H815138e15 261815262815273(115274915277815278R15279815211181530181530Q8153918153<J2815397815399815421IH5422815428B1615281&8018161109!l168l::!816811811101'317111818496

OESCR IPT ION

,..AT LUGGAGE FLOORPANEL ASSEMBLY DASH FRONT L H S. L HCHANNEL ASSEMBLY STEERING COLUMN SUPPORT RHSCHANNEL ASSEMBLY STEERING COLUMN SUPPORT LHSPADDING ASSY fACIA LOWER PASSENGERS SIDE RHSPADDING ASSY FACIA LOWER PASSENGERS SIDE LHSPADDING ASSY FACIA LOWER DRIVERS SIDE R H S.PADDING ASSY FACIA LOWER DRIVERS SLOE 1 H SPANEL ASSEMBLY B POST OUTER L HPANEL ASSEMBLY B POST OUTER R HPARCEL TRAY ASSEMBLY {DRIVERS SIOEI L H SPA~CEL TRAY ASSEMBLY (DRIVE~S SIOEI L H SPARCEL TRAY ASSEMBLY(PASSENGERS SIDEI R H SPA~CEL TRAY ASSEMBLY{PASSENGERS SIDE) L H SPANEL TRLNK LID GUTTER SIDE L HPANEL TRUNK LID GUTTER SIDE R HTUBING ASSEMBLY MOTOR TO WHEELBOXPANEL DASH SHELF l H'SPANEL DASH SHELF R H SAIR BOX ASSEMBLYBRACKET SUPP('RT TRUNK LIO HINGE L HBRACKET SUPPORT TRUNK LIC HINGE R HHtADER RAIL HOOD FITTINGREINFORCEMENT BONNET FRONTFRONT GRILLE CENTREMOULDING (CHROMEI REAR .ENO SlOE L HMOULDING {CHROMEI REAR END SIDE R HCATCH PLATE HOOD CLOSURE WINDSCREEN l HCATCH PLATE HOOD CLOSURE WINDSCREENR·H

. FINISHER B POST rop L HFINISHER B P0ST TOP R HPANEL OUTER REAR WING L HPANEL OUTER REAR WING R HHOODSTICK NO 1 & LINKS NO 4 ASSEMBLYHOOOSTICK NO 2 & LINKS Ne 6 ASSEMBLYUNDERIDER FRONT L HUNDERIDER FRONT R HTxUNK FLCOR ASSEMBLYCRASH PAC ASSEMBLY FACIAHOOD SEWN ASSY BLACKHOOD SEWN ASSY WHITEFRONT VALANCE CORNER PANEL ASSEMBLY L HFRONT VALANCE CORNER PANEL ASSEMBLY R HWINDSCREEN ASSEMBLYPANEL ASSEMBLY REAR DECKMECHANIS~ RECLINING L H!"ECHANIS" RF.CLINING R fiGLASS BACKl IGHTSTRAP ASSY SQUAB BOTTOM INTERMEDIATESTRAP ASSY SQUAB BOTTOM CENTRE (UPPERISTRAP ASSY SQUAB TOPSTRAP ASSY SQUAB TOP INTERMEDIATESTRAP ASSY SQUAB CfNTRE (LOWER)CARPET SIll L HCARPET SILL R. HGLASS WINDOW

809716

REF. NO.

10-6010-2910-2710-2710-3910-3910-3910-3910-3?10-3010-4010-4010-4010-4010-3010-3010-1010-2910-2<)10-2<)10-3010-3D10-5210-3110-3310-5110-5110-5410"'5410-5110-5110-3010-3010-5210-5210-4610-4610-2810-3910-5310-5310..,.3310-3310-3810-3010-6410-6410-6510-64lO-6't10-6410-6410-6410-5910-59

B1S't96

PART NUMBER

8184988136258186268187618' R771'l1878:)81i!7':I5818786818 gOtB188118188318188418188718188728lB 8AS81894181q94481'19518189618198018198028198038198048198078198088198(19819884$11995987.'38382053582:>53682J71.S82116482H65821166821.1,03i\?l6238211<;382237182237'18224018224038224078224318224338224378224518224')98224618 n-4!>9822491

- 82?49982250t82250"18l?55'l822559

OESCR IPT lCN

MOULDING HARD TOP REARREINFORCEMENT ASSY FRONT WING SIDE L HREINFORCEMENT ASSY FRONT wING SIDE R HCOVER REAR LAMP L HCOVER REAR LAMP R HPANEL ASSEMBLY DA$H fRONT L H S R HPANEL ASSEMBLY DASH fRONT R H S L HPANEL ASSEMBLY OASH FRONT R H S R HSEAL QUARTER VENT I HSEAL QUARTER VENT R HCOVER Hocn LINKAGE L HCOVER HOCD LINKAGE R HPANEL ASSY WING TO wHEfLARCH&HLAMP REINFOR LHPANEL ASSY FRONTWING·TO WHEELARCH&HLAMP RE RHBOARD CASING PETROL TANK REARSEAT StICE ASSY L HSEAT SlIC~ ASSY R H~OARO FRONT SEAT CUSHION L HBOARD FRCNT SEAT CUSHION R.HINSIDE OOORHANDLE ASSY&REMOTE CONT MECHAN LHINSIDE nCORHANDLE ASSY&REMOT.E CONT /'IEeHAN RliBEIEL TRIM INSIDE DOOR HANDLE L HBEZEL TRIM INSIDE DeOR HANDLE R HLINK REMeTE CONTROL DOOR L HLINK REMCTE CONTROL DOCR R HROD ASSE~BLY LOCKING IIN~

GLASS FRONT DOORGLASS BACKLIGHT HARD TOPHACKL IGHT HOODSEAT SLICE ASSY L HSEAT SL Ice ASSY R HVALANCE ASSEMBLY ENGINE BAY R HVENT ASSEMBLY REAR QUARTER HARO TOP L HVENT ASSEMBLY REAR QUARTER HARD TOP R HGLASS REAR QUARTER VENT HARD TOPHOOD STOWAGE COVER ISOFT TOPI NEW TANHOOD STD.AGE COVER (HARD TOPI NEW TANREAR TR P' BOARD NEW TANHOOD SEW~ ASSEMBLY BLACKPOOO SEW~ ASSEMBLY WHIT~

HOOD STO~AGE COVER (SOFT TOPI BLACKHOOD STOWAGE (OVER (SOFT TOPI CHESTNUTHOOD STOWAGE COVER (SOFT TOP' SHADOW BLUEHOOD STOIIAGE COVER (HARDTOP I BLACKHOOD STOIIAGE COVER (HARD TOPI CHESTNUTHOOD STOkAGE caVER lHARD TOPI SHADOW 8LUE,ONNEAU COVER ASSEMBLY IBLACK R H STONNEAU COVER ASSEMBLY (WHITEI R H STONNEAU COVER ASSEMBLY BLACK L H STONNEAU (OVER ASSEMBLY WHITE L H STONNEAU COV ASSY BLACK RHS(HEAO RESTRAINT TVPTONNEAU COV ASSY WHITE RH5lHEAD RESTRAINT TYPTONNEAU COVER ASSY BLACK L H SUS ATONNEAU COVER ASSV WHITE L H S USACOVER CONSOLE BRACKETWATER CURTAIN FRONT DC OR

REF.NO.

10-51>10-3110-3110-1510-1510-2910-2910-2910-5610-5610-5410-5410-3110-3110-6010-6810-6810-6710-6710-3510-3510-3510-3510-3510-3510-3510-3410-5610-5310-6810-6810-3310-5610-5610-5610-6110-6110-6010-5310-5310-6110-&110-6110-6110-6110-&110-5010-5010-5010-5010-5010-5010-5010-5010-4010-37

818498 822559

PART NUMBER

B226118226138226178226718226918232B823224823311a23 32182338182't54082105(,08210612821061382't618821061992ft 790.82479182'>794821+791+82107958247959030'H9030989031329031349056549082699085219C89009C89079089089089709089769090299093289093519('\9352909661909662909663909664909797909798910501910961910962911 040911081911 082911101911102911106911107'HilOa911140

OEseR IPT ION

REAR TR I M BOARD~EAR TRI~ BOARD CHESTNUTPEAR TRIM 80ARD SHADOw BLUECARPET ASSEMBLY REAR FLOOR BLACKBRACKET ASSY CONSOLE SUPPORTCOVE~ Hoeo LINKAGE FRONT L HCOVER -HOOO LINKAGE FRONT R HSUN VISOR PASSENGERS SIDE R H SSUN VISO~ PASSENGERS SIDE L H SSUN VISOR DRIVERS SlOEVENEERED FACING ASSY (CAR SETI RHS (8 A 0 RlVENEERED FACING ASSEMBLY LHS USAREAR IMPACT SHOCK ABSO~BER ASSY L HREAR IMPACT SHOCK ABSORBER ASSY R HFRONT IMPACT SHOCK ABSORBER ASSY L HfRONT IMPACT SHOCK ABSORBER ASSY R HREINFORCEMENT UPPER REAR IMPACT L HREINFORCEMENT UPPER REAR IMPACT R HREINFORCEMENT LOWER REAR IMPACT L HREINFORCEMENT LOWER REAR IMPACT LHREINFORCEMENT LeWER REAR IMPACT R HREINFORCEMENT LOWER REAR IMPACT RHPANEL SILL OUTER L HPANEL SILL OUTER R HSEAT PAN REARPANEL HEELBOAROPAD SOUND DEADENING REAR SEAT PANBONNET TOP ASSEMBLYPANEL ASSEMBLY FACIA ToPPANEL MA,lN FLOORPANEL OUTER REAR WINGPANEL OUTER REAR WING R HVALANCE ASSY REAR tOWERGLASS WINDSCREEN LAMINATEO HIGH IMPACT INTERlWEATHER STRIP WINDSCREEN GLAZINGGLASS WINDSCREEN LOUGHENEO (ZEBRA ZONEDlPANEL fRCNT WHEELARCH OUTER l HPANEL fRONT WHEELARCH OUTER R HPANEL WHEELARCH OUTER L HPANEL WHEELARCH OUTER R HSIDE FRO~T WING L HSIDE FRD~T WING R HPANEL fRONT WHEEL ARCH IN~ER L HPANEL FRONT WHEELARCH INNER R HHEATER ASSY [PERMANENT MAGNET MOTORIFACIA PANEL ASSY R H SFACIA PANEL ASSY L H SRUBBER BACKLIGHTSUPPORT ASSEMBLY OUTER VALANCE L HSUPPORT ASSEMBLY OUTER VALANCE R HHEADLAMP SURROUND ASSEMBLY L HHEAOlAMP SURROUND ASSEMBLY R HCAPPING ~INOSCREEN

TUBE ASSEMBLY BONNET FRO~T l HTUBE ASSEMBLY BONNET FRONT R HFRONT BU~PER ASSEMBLY

822611

REF. NO.

10-6010-6010-601('-5910-4010-5410-5410-3810-3810-3810-391/) 3910-4810-4810-4610-4610-2810-2810-2610 4810-2810 4810-2910-2910-2810-2710-6010-3110-2910-2710-3010-3010-2810-38l()- 3810-3B10-3110-3110-2810-2810-3110-311('-3110-3110-4210-3910-3910-5610-3310-3310-3210-3210-5110-31lo-,n10-46

911140

PART NUMBER

'1111499111<;0911271'H1272911 27,911274911 327912846912977912.978912919'11298')'113147913748913 75091376391~ 764913817'H3818913819913 8119t38329BB3391469591'>6'l69146<)8915361915362915633915634916401'lIMO;?911248911249'n7569917570917<;'19917600917629917630911631911638917668'l1821!).9182209182309182509\85019185039185079185H918513918517918501918561918567

OEseR IPT ION

HOOD FRA~E ASSEMBLY~EINFOR TUBE TRANSV&BRKT ASSY WH/ARCH TO eONNWINDOW REGULATOR ASSEMBLY L HWINDOW REGULATOR ASSEMBLY R HBASKET wIRE FRONT SEAT CuSHION L HBASKET wIRE FRONT SEAT CUSHION R HTRUNK LIC ASSEM8LYMAIN FLOCR ASSEMBLYA POST&FRONT SIll REINFORCEMENT ASSY lHS lHA POST&FRDNT SILL REINfORCEMENT ASSY LHS RHA POST&FRONT SILL REINFORCEMENT ASSY R~S lHA POSTAFRONT SIll REINFORCEMENT ASSY RHS RHTORSION BAR l HTORSION eAR R HBRACKET SAFETY CATCH MOUNTINGBONNET ASSEMBl YBO~NET ASSEMBLYBODY SHELL PRIME FIN RHSILESS DOOR BDNFRONTBODY SHEll PRIME FIN lHSllESS DOOR BON FRONTBODY SHELL PRIME FIN lHS USA ONLYILESS DOORSBODY SHELL PRIME FIN RHSICOMP WlTH DOORS BONNBODY SHELL PRIME FlN lHSICOMP wITH DOORS BONNBODY SHElL PlUME FIN LHS USA ONlYICOMP WITH DDOOR LOCK ASSEMBLY l HODOR LOCK ASSEMBLY R HREAR BUMPER ASSEMBLYODOR ASSEMBLY L HDOOR ASSEMBLY R HOUTsIDE COOR HANDLE ASSEMBLY L HOUTSIDE COOR HANDLE ASSEMBLY R HFRAME ASSEMBLY FRONT SEAT l HFRAME ASSEMBLY FRONT SEAT R HMOULDING W/SCREEN L HMOULDING W/SCREEN R HFRONT DOOR AS$Y L HFRONT DOCR ASSY R HPAD ASSY SQUAB l HPAD ASSY CUSHION R HPAD ASSY CUSHION L ~

PAD ASSY CUSHION R HPAD SIDE & CENTRE CUSHION FRONT ROLL L HPAD SIDE & CENTRE CUSHION FRONT ROLL R HGLASS WINDSCREEN HIGH IMPACT INTERlAYERVENEERED fACINGS ASSY CAR SET L H SVENEERED FACINGS ASSY ICAR SEn LHS DUAL BRKSVENEERED FACINGS ASSY CAR SET R H $VE~EEREn FACINGS ASSY CAR SET L H 5 U·$ AfRONT SEAT WITH HEAD RESTRAINT BLACK L HFRaNT SEAT WITH HEAD RESTRAINT CHESTNUT l HFRONT SE~T WIT~ HEAD RESTRAINT SHADOW BLUE lHFRONTSEAT ASSY L/CLOTH HEAD RESTRAINT BlK RHfRONTSEAT ASSY L/CLOTH HEAD RESTRAINTCHFS RHFRONTSEAT ASSY l/CLOTH HEAD RESTRAINT SIBL RHfRONT SEAT ASSY BLACK L HFRONT SEAT ASSEMBLY CHESTNUT lHFRONT SEAT ASSEMBLY SHADtw BLUE L H

REF.NO.

10-5210-3110-35to""3510-6710-671 :>-4510-2710-2910-2910-2910-2910-6410-6410-6410-3110-3110-2410-2410-2410-2"10-2410-2410-3510-3510-4110-3410-3410-3510-3510-6410-6410-3810-3B10-3410-341~-65

10-6510-6110-6110-6710-6110-3810-3910-3910-3910-3910-6310-6310-6310-6310-6310-6310-6210-6210-62

911149 918567

PART NUMBER

«16571'l18573'H8571918621911l6?3918621«\8631918633'H '36319t86819185839186819186919166'n9181;91918741918143918747918771918713918777918781918 783'H8787918 B31918833918837918841'H8843'1\6841

, 92'05092216'l922161922463922413922523922533922583922593922643'l22653922703'l221339127439227939228'>3923896

AHH 5301AHH 6504AKD 775'lAUD 3308AUO 3310AUD 5 BOFAUD 5 BOP.AUD 9095AUD 9254

OESCR IPT ION

FRONT SEAT ASSEMBLY BLICK P. HFRONT SEAT ASSEMBLY CHESTNUT PHFRONT SEAT ASSEMBLY SHADOW BLUE R HCUSHION ASSEMRLY BLACK L HCUSHION ASSEMBLY CHESTNUT L HCUSHION ASSEMBLY SHADOW BLUE L HCUSHION ASSEMBLY BLACK R HCUSHION ASSEMBLY CHESTNUT RHCUSHION ASSEMBLY SHADOW BLUE R HfRAME & SQUAB ASSEMBLY BLACK L HFRAME & SQUAB ASSEMBLY CHESTNUT L HFRAME " SQUAB ASSEMBLY SHADOjj BLUE L HFRAMe & SQUAB ASSEM8LY BLACK R HFRAME & SQUAB ASSEMBLY C~ESTNUT R HFRAME & SQUA8 ASSEMBLY SHADOW 8LUE R HHEAD RESTRAINT BLACKHEAD RESTRAINT CHESTNUTHEAD RESTRAINT SHADOW BLUEFPONT SE~T l/CLOTH WITH ~EAD RESTRAINT BLA lH~RO"lT SEAT lICLOTH WITH !'EAD RESTRAINT CHE LHFRDNT SEAT l/eLOTH WITH HEAD RESTRAINT SIB LHFRONT SEAT WITH HEAD RESTRAINT&SENSOR BlAC RHFRONT SEAT WITH HEAQ RESTRAINT&SENSOR CHI'S RHfRONT SEAT WITH HEAD RESTRAINT&SENSOR N/TANRHCUSHION ASSY LEATHERCLOT~ L H BLACKCUSHION ASSY LEATHERClOTH L H CHESTNUTCUSHION ASSY lEATHERClOTH l H SHADOw 8lUECUSHION ASSY (WITH SENSOR) BLACK R HCUSHION ASSY (WITH SENSOR) CHESTNUT R HCUSHION ASSY (WITH SENsQR) SHADOW BLUE R H"EAR BlIMPER· ASSEMBl YHANDLE ASSEMBLY DUTSIDE DOOR l HHANDLE ASSY OUTSIDE DOOR R HFRONT SEAT WITH HEAD RESTRAINT NEw TAN l HFRONT SEAT ASSY L/ClOTH wITH HEAD RESTRAI~T

fRONT SEAT ASSEMBLY NEW TAN L HFRONT SEAT ASSEMBLY NEW TAN R HCUSHION ASSEM8LY NEW TAN L HCUSHION ASSEMBLY NEW TAN R HFRAME AND SQUAB ASSEMBLY NEW TAN l HfRAME AND SQUAB ASSEMBLY NEW TAN R HHEAD RESTRAINT NEW TANFRONT SEAT llClOTH HEAD RESTRAINT NEw TAN LHFRONT SEAT WITH HEAD RESTRAINT&SENSOR N/TANRHCUSHION ASSEMBLY lEATHERCLOTH l H NEW TANCUSHION ASSEMBLY (WITH SENSOR) NEW TAN R HSPOILER FRONT VALANCEBUSH BEARINGTUBE DISTANCE PEDAL TO BRACKETPASSPORT TO SERVICE ENGLISH EUROPEANSCREW NEEDLEGUlOE NEEDLECARBl/RETTOR FRONTCMBURETTOR REARNEEDLE A~O SEAT ASSEMBLYLID FLOAT CHAMBER ASSY

10-6210-6210-6210-6710-6711)-6110-6710'-6710-6710-6410-6410-6410-6410-6410-6410-6610-6610-6610-6310-6310-6310-6310-6310-6310-6710-6710-6710-6710-6710-6710-4B10-3510-3510-6310-6310-6210-6210-6110-6710-6410-64

·10-6610-6310-6310-6710-6710-3309-60·09-60·09-8409-3209-3209-3109-3109-3209-32 '

918571 AUO 9254

PART NUMBER REF.NO.

09-3210-1909-4010-1609-4010-1610-7910-7909-8210-60

·10-1210-1209-3210-6510-6510-6409-3809-2309-3709-0709-0409-0409-0409-)810-7909-5709-4109-2109-4209-6010-6010-1310-7310-1310-1310-131.0-13IP-73 .10-1310-7310-7310-1310-7310.,7309-8309-8)09-8309-7109-70o9-io

. 10-0510-0509-0609-0609-0509-14

OESCR IPT ION

LID FLOAT CHAMBER fRONT ~ARBURETTOR

RIVET ROKUTBALLBALL 1132 IN VALVE aODY8AtlBALL 3/16CONE CHANGE SPEEO LEVERNUT RETAINING GEAR LEVER KNOBTHER~OSTATIC VACUUM SWITCHWASHER CUPPLUG HEfLBOARO XMEMBERI5/8 HOLEIPAINT DRAINAGPLUG RUBeER 13/8 HOLEI HEEL BOARD PANELOAMPER ASSY CARBWASHER FINISHER HEAD RESTRAINTFYELET HEAD RESTRAINTSPRING RCLLEROOWEL FRONT END COVER TO CLUTCH HOUSINGDOWEL CLUTCH TO FLYWHEEL ATTACHMENTDOWEL TOP COVER EXTFNSIONDown Fl YWHEELDOWEL TRIMMING COVER ATTACHMENTnOWFL 3/8 GEARBOX&REAR ENGINE PLATE ATTACHMEDOwEL 1 GEARBOX&REAR ENGINE PLATE ATTACHMENTDOwEL IN THRUST PLUGDOWEL SPRING TENSION ACTUATOR TO SHAFTDOIIELDOWEL SPRING TENSION COUNTERSHAFT LOCATINGDOWEL SPRING INLET MANIFCLO TO HEADDOWEL COUPLING TO GEAR LEVER· SHAFTFIX REMOIiAgLE TURE TYPERETAINER NUT fETROL TANK CASING BOARDPAINT AEROSOL BLACK SATIN MATTPAINT AEROSOL WHITEPAINT AEROSOL SIENNA BRCwNPAINT AEROSOL DAMSONPAINT AEROSOL SAFFRONPAINT AEROSOL PIMENTOPAINT AEROSOL SAPPHIRE eLUEPAINT AEROSOL EMERALD GREENPAINT AEROSOL MALLARDPAINT AEROSOL FRENCH BLUEPAINT AEROSOL CARMINEPAINT AEROSOL MAGENTAPAINT AEROSOL MIMOSAFLUID BRAKE & CLUTCH aoz TINFLUID BRAKE t CLUTCH 16 01 TINFLUID BRAKE & CLUTCH 32 01 TINHOSE ASSE"'BLYPAD LIN I "GBRAKe·SHCE ASSEMBLYCONTACT SETCAP ASSEIIBLVGASKET CYLINDER HEADWASHER JCINT ROCKER COVER TO CYLINOERHfADWASHER JCINT BETWEEN SUMP&CYLINOER BLOCKGASKET MANIFOLD

92514398)012:lOll,.3016:lOlO

3350530623

031430241522'i6722116q41034-26345004113n05)4L')

'411'414:>51406100616:>914131513351908251225161301434044

144153161161216271278281282301302303304

.2012'l2203202161544105123313414511

.648

AunBHABLBtaLaLCCCCDCOenCUDCZACZACZA01'01'01'01'01'01'01'OSOSososOSDSFGFlGAPGAPGAPGAPGApGAPGAPGAPGAPGAPGAP ..GAPGAPGarGBFGBFGBHGBpGBSGCSGOc.GE.GGEG.GEGGE.G

Aua 9257 GEG 648

PIRT NUMBER OESCR IP TION REF. NO.

GEG,GEXGEXGEXGEXGFI'IGFR(iFEGFEGFGGFSGFSGFlfGHBGHBGHBGHBGtlSGHSGLI'IGLBGLBGLBGLAGLBGLAGLBGLUGLUGLUGMCGR'AGI> AGRCGllHGRHGSBGSCGTGGTSGTSGTUGTUGTIjGTUGTt!GTUGTUGTU(iTUGTUGTUGTUGTUGUJGWe:

10114393'3727'32973,el

14215111'1

1037117

2535

107lOS110111In111146207254380382411S/H9879891"'1114513205lli);>D711426C1265102104t0311)410614415316116727627727828128230130;>303304106

1202

GASKET FRONT EXHAUST PIPE TO MANIFOLDFRONT EX~AIJST PIPE ASSEMBLY'REAR SILFNCER & PIPE ASSEMBLYGROMMET BRACKET TO AXLE MOUNTING PLATEGROMMET .ASHER BRACKET TO AXLEFAN BEL TFAN Bel TOIL FILTER ASSEMBLY (ALI TO 1565Bl1

'ELEMENT AIR CLEANERWASHER JCINT OIL SEALFUSEFUSEHASHER UNITBEARING CIFF CASING TO HYPOIO HOUSING8EARING CUTER HUBBEARING INNER HUBBEARING BALL REAR HUBSEAL OILSEAL OIL ASSY BETWEEN VERT LINK&INNER BEARING[JULBflULBBULBBULB FLASHERPULB 12V 45101/50101 YELLOwBULBBULB IGNITION SWITCH ILLUMINATIONBULB 51 DELIGHT UN ITLIGI-lT UN ITUGHT UN tTCLUTCH MASTER CYLINDER -ASSEMBL YROTOR AS SEMBL YPEAR INC CLl/TCH THRO" OUTCAP FILLER ASSEMBLY 113lB PRESSUREIHOSE TOP RADIATOR TO wATER ELBOWHOSE BOTTOM RADIATOR TO wATER PUMPBRUSH SET 'CONDENS~R PACKAGEGASKET WATER ELBOW TO WATER PUMPTHERMOSTAT UNIT (82 DEG C OPENING)THERMOSTAT UNIT (88 OEG C OPENINGITOUCH UP PAINT MATT BLACKTOUCH IN PAINT DETAILS wHITETOUCH IN PAINT DETAILS SIENNA BROWNTOUCH IN PAINT DETAILS DAMSONTOUCH IN PAINT DETAILS SAFFRONTOUCH IN PAINT DETAILS PIMENTCTOUCH IN PAINT DETAILS SAPPHIRE BLUETOUCH IN PAINT DETAILS EMERALD GREENTOUCH IN PAINT DETAILS MALLARDTOUCH IN PAINT DETAILS FRENCH BLUETOUCH IN PAINT DETAILS CARMINETOUCH IN PAINT DETAILS MAGENTATOUCH iN PAINT DETAILS MIMOSAUNIT PACKAGEREAR WHEEL CYLINDER ASSEMBLY 5/8 oIA

09-BO09-8009-80 '09-8009-80 '09-0909-2509-1009-3009-5110-13

'10-1'110-0909-52 '09-4709-4709-5109-5109-4710-1610-1610-1410-1410-1310-1610-1910-1410-13

,10-1310-1309-6510-0509-3809-8209-82'09-B210-0710-0509-09OQ-2509-0910-7310-1310-7310-7310-7310-1310-7310-7310-7310-7310-73 '10-1310-1309-5709-70

GEG 701 GWC 1202

PART NUMBER

KW 0316!II 9YNKC 0009NKC 0010NKC 0011NKC 0012NKC 0013NKC ()()14'1KC 0015NKC 0016NRC 1)017NKC 0018NKC 0020NKC 0021!liKe 0022NKC 0023NKC 0024NKC 0025NKC 'l'126NKC onaNKC 0029NKC 0030"JKC 0031NKC 00'38NKe 0039NKC 004QNKC 0041NKC 0042NKC ;)043NKC 0045NKC 004'!NKC 0053NKC 0055NKe Cl0'57NKC 0058NKC 0059NKC 0062NKC 0063NKe 0064NKC <0066<NKG'< 0067NKC COb'!NKC 0070NKe 0076NKC 0361~KC (l293~KC D918

<1<KC 0959RTC 0468RTC0469RTC 0470RTC 0471

< "TC < 0472RTC 0473RTC '1490~TC "1)40

OESCR IPTlON

KEW<WOODRUFF SECURING CAMPLUG SPARKINGANNULUSBRAKE RII\GwASHER PRESSURE FILTERCLUTCH SPRING KITDASHPnT PLUG KITDASHPOT SLEEVE KITDASHPOT PISTON KITFREEWHEEL P.INERfREEWHE ELK ITMAIN CASE KITOIL THROl-ERPISTON OPERATING KITPLANET CARRIER KITFILTER PRESSUREPLUG PRESSURE FILTERPUf>1P '300'1' KITPLUG KIT PUf>1PPLUNGER KIT PUMPNO~ RETlJRN VA l VE KITRELIEF VALVE BODY KITPISTON KIT RELIEF VALVEREAR CASEOIL SEAL REAR CASESLIDING "EMBERVALVE SOLENOIDSPEEOO BEARING KITCONNECTOR SPEEDOGEAR SPEEDO DRIVINGGEAR PINION SPEEOOFILTER SUCT IONSUNWHEfLSTun SET MAIN CASE ADAPTeRSTUD SET MAIN CASE REAPSTun SET MAIN CASE REARTHRUST BEARING HOUSING KITTHRUST BEARINGSETSCREwNAMEPLATE (LILAC)EARTH WIRE (SOLfNOIDlNUTSPRING WASHERSUMP GASKETRIVET WHEELA.RCHCYLINDER BLOCK ASSEM8LY

. ClUINKSHAFTMAIN HAR~ESS lHS USASPRING T~ROTTlE RETURNSTARTER. ASSEMI'lLYSCREW THROTTLE STOPLOCKNUTVALVE 8Y-PASS ASSEMBLYNEEDLE SEATING ASSEMBLY ~ITH ALTERTHRC'TTLf LEVERCONVERTER MASK HEADlAMP

KW 0316

10-,7610-0410-81la-aD10-8010-8110-8310-8310-8310-8110-8110-8010-8110-8010-8110-8010-8010-8310-8310-B310-8310-8310-8310-a210-8210-8110-8010-8210-8210-8210-8210-8010-8110-8010-8010-8010-8110-13110-8010-8010-8010-8010-8010-8010-7209 0409-0710-2109-1809-18

, C9-1809-t809-1 B09-1809-f910-13

RTC 0540

PART NUMBER OESCR IPTION REF. NO.

RTCRTCRTCRTCRTCRTC'lTCRTCRTCRTCRTCSPTKCTKCTKCTKCTKCTKCTKCTKeTKCTKCTKCTKCTKCTKCTKCTl(CTKCTKeTKCTI(CTLUKCUI(CUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUI(CUKCUI(CUK·CUKCUKC·

)5530709H69J1690770J771IOOb1174117511761\77

918301780220nA40394:l41904301)41904841533() 580058107341770tl89909233924()944

·11121186IS4\)OOll() 565)'56806730697HOb)72207253731D764::In90856OB940913093009330934093';()9360'1370946() 9591110'1157

STUD SET FOR OVERDRIVE 10-80COIL & LEAD KIT 10-04!VENTILATION LEVER 09-19LINER 09-19SCREW T&ROTTLE STOP 09-19SPRING 09-19BASE AND RETAINER INTERIOR MIRROR 10 38LENS REVERSE LAMP 10-15GASKET REAR LAMP CLUSTER SEATING 10-15lENS FLASHER REAR AMBER 10-15LENS STOP TAIL LAMP 10-15RIVET ANCHOR PLATE TO TIMING COVER 09-08STOP/TAIL FLASH REFLEX&REVERSE LAMP PH 10-15REAR AXLE HOUSING ASSY 09-52E G R VALVE 09-13STOP/TAIL FLASHER REFLEX&REVERSE LAMP L H 10-15oISTRlBUTOR ASSEMBLY 10-04PLATE DRIVEN CLUTCH 09-35REAR ROAO SPRING ASSY(MAt~&SECONoARY BLADESI 09-55PLATFORM REAR ENGINE MTG 09-44MAINSHAFT 09-40FRAME EXTENSION ASSY R ~ 09-45FRAME EXTENSION ASSY L ~ 09-45CONTROL BOX INTERLOCK SEH BELT 10-19PRDPELlOR SHAfT ASSEMBLY 09-57MAINSHAFl IJ TYPE OVERORlVEI 09-40MAINSHAfT (OVERDRIVE) 09-40BOTTOM HOSE & VACUUM SWITCH ASSEMBLY 09-82BODY HAR~ESS (SINGLE LEVELl 10-21IGNIT ION SWITCH 10-09FLYWHEEl ASSEMBLY 09 07R YWHEEl ASSEMBLY 09-07SLEEVE TUBING PIPE TO ACAPTOR GASKET CARB 09-14SHORT ENGlNE (1300CC) 09-20SH'JRT !'NGINE 09-04BRACKET ASSY STARTER WITH CLIP 09-19STUB AXLE 09-47SLEEVE 1ST SPEED SElECTCR SHAFT 09-39CLI P SPEECO iO-82SHIELD PINION. NUT 09-53APPROVAl LABel 10-72PINION FLANGE&STONE GUARD SUB ASSEMBLY 09-53WASHER ft,RUST 09-40BODY HAR~ESS IDUAL LEVEll 10-21STRAP STEERING LOCK RETAINING 09-58SPARKING PLUG N 12 Y 10-04SWITCH OVERDRIVE INHIBITCR 10-19BUSH FLANGED 2ND SPEED GEAR 09-40THRUS T WASHER 1.1<)8 /.2oe ) 09-40THRUST~ASHER 1.201 /.203 I 09-40THRUST WASHER (.204 /.206 ) 09-40THRUST WASHER 1.207 /.209 ) 09-40EMISSION CONTROL SETTINGS LABEL 10-29GEARBOX ASSY LESS TOP COV EXfEN&H/LEVERIJ TYP . 09-37OIL SEAL IHELIX TYPE 01-08LEAD EXTENSION REVERSE LAMP (ITALYI 10-79

RTC 0553 UKC 1157

PART NUMB ER

UKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKfUKC'UKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKCUKC

llllD12761281131:>133213351336136013611363137-0141314261427142814501489157715901591165516561657165816~9

166616751676176417881813184619051908191019251 'Po 719~8

2Cl642109211021302184221122122284;> 598261326142616267127191

'2719327201272027.781

OESCR I PT ION

LABFL EMISSION CONTROL SETTINGS lCANADAlRRAKE PHAL ASSYREAR AXLE CFNTRE ASSYBALL JOINT UPPER WISHBONESURGE PReTECTION DEVICE ALTERNATORVACUUM CONTROLPIN COUPLINGLEAD BATTERY POSITIVE TO SOLENOIDLEAD BATTERY NEGATIVE Ta EARTH IL HS.LEAD SOLENOID TO STARTERACCELERATOR PEAOL~MOUNTING BRACKET ASSYNUTCYL HEAD ASSYIANTI-POLLUTIONIC/W VALV&SPRINGSCYL HEAD ASSYl1300 H CI C/W VALVES&SPRINGSCYL HEAD ASSY(130Q L CI CGMP WITH VALV&SPRINGGEAR 2NO SPEEDBODY HARNESSREAR AXLE CENTRE ASSY RECONDITIONED UNITCLIP RETAINING MASTER LIGHT SWITCHSWITCH MASTER' LIGHT (OFF SIDE HEADICOVER AL TERNATORREGULATOR ALTERNATORRECTIFIER ALTERNATORBRACKET SLIP RING & ALTERNATORSTATOR ALTERNATORBRACKET DRIVING END ALTERNATORRIM ASSE~BLV SIDE AND FLASHER LAMPLENS ASSEMBLY SIDE AND FLASHER LAMPPETROL PIPE ASSEMBLYRELAY LEVER SUB ASSYeIPE ASSEMBLY E G R VALVE TO INLET MANIFOLDBANJO BOLTSLEEVE STRA IGHTSWITCH REVERSE LIGHTBRACKET EXHAUST TAIL PIPE SUPPORTBRKT MOUNTING FUEL TRAPDOWEL CLUTCH TO FLY~HEEL

OQWEL CL~TCH TO FLYWHEELCHOKE INNER & KNOB ASSE~BLY (PROCTORIPIPE VACUUMPIPE VACLUt.4T PIECELEAD LOUDSPEAKERCAPACITOR SUPPRESSION COILCAPACITOR SUPPRESSION ALTERNATORWASHERBOLT CONNECTING RODVACUUM PIPEVACUUM PIPE T JUNCTION TC CARSURETTORVACUUM PIPECHOKE INNER & KNOB ASSY IS J CLARKISTEER COL LOCK&IGNIT SWITCHIOUT BUZl CONT ~AS

STEEP. COL lOCK&lGNIT SWITCHIOUT BUZl CONI~ILM

STEER COL LOCK&IGNIT $WITCHlwITH BUZl CONTISTEER COL LOCK&IGNIT SWITCHI WITH BUll CONJIH T LEAD-COIL TO 01 STRIBUTOR

REF. NO.

10-2909-6409-5109-4710-0610-0510-0510-2010-2010-2109-6009-1~

09-0609-2209-2209-4010-2109-5110-1810-1810-0610-0610-0610-0610-0610-01>10-141'1-1409-71>09-681)9-1309-1309-1210-1909-8109-1209 0709 0710-1809-1209-1209-1210-2210-2210-2209-1409 0109 1209 1209 1210-1809-5809-5809-5809-5810-04

UKC 11 80 UKC 2781

PART NUMB ER

UKC 27!l2UKC 27B3UKC 2784UKC 3193··UKC 3208UKC 3793UKC 3795WKC 1145XKC 0531YKC 1288YKC 0'541YKC (l686YKC 0&88YKC 0&89YKC193::lYKC 0931IKC flB6IKG 0037IKG 0038IKC ')191IKC 03501I<C 0412II<C ')511IKC 0517IKe 0533IKC :>751II(C ')759IKC 0864IKe 0867IKC 1256IKC 125712H ·429513H 142821H 547821H 54792JH 596760 9376;)990 36448090 559061

DESCR I PT ION

H T LEAD NO 1 AND 3H T LEAD "lQ 2H T L EAO NO 4LABEL EM1SSION CONTROL SETTINGLABEL EMISSION CONTROL SETTINGCLIP VENT PIPE PETROL TA~K

CLIP PIPEREAR BUMPER ASSEMBLYAERIALBOARD MOUNTING LOUDSPEAKERLOUDSPEAKERMIRROR ASSEMBLY DRIVERS EXTERIORDRUM ASSY MIRRORWASHER SEATING EXTERIOR MIRRORSWITCH IGNITION WARNING IDOUBLE BLADEISWITCH IGNITION WARNING (DOUBLE BLAOEISETSCREW CROSS RECESSED DOOR LOCK ATTACHMENTSETSCRFW LONGLOK CROSS RECESSED STRIKER A POSSETSCREW CROSS RECESSED DOOR STRIKER A POSTPLUG BLA~KING FLOORLA8EL WI~OSCREEN

BEZEL AND GRILLEDPIVE FASTENERBRACKET LOUDSPEAKER BOARDLEAD AERIAL JUMPERBUTTON BLACKBUTTON WHEBRACKET REAR IMPACT SHOCK ABSORBERCUP SUPPORTBRACKET SPACER UNDER HOR~ MOUNTING BRACKET LHBRACK ET SPACER U~DER HORI\ MOUNt! NG BRACKET RHbNTI-RUN-ON VALVECLIP DOUBLE NYLON HYDRAULIC PIPESCASING DIFFERENTIALBOLT CROhN WHEEL TO DIFFERENTIAL CASINGHOSE REAR BJ\AKECLIP ASSEMBLY R C HANDLE LINKAGECLI P ANTI-RATTlESWITCH LOCK ILLUMINATION (SINGLE BLADEI

REF.NO.

10-0410-0410-0410-2910-2909 7609-3110-4810-3010-4010-4010-3410-3410-3410-19

'10-1910-]510-3510-3510-7210-3810-4010-4810-4010-2210 6110 6110-4810-4609 4509 4509-7809 1109-5209-5209-7410-3510-3510-19

UKC 2782 '10 559061

Documents

Triumph Spitfire mkIV 1973 and Spitfire 1500 Parts Catalogue