View
7
Download
0
Category
Preview:
Citation preview
Ope
rato
r’s M
anua
l
Operator’s Manual
THIS IS A MANUAL PRODUCED BY JENSALES INC. WITHOUT THE AUTHORIZATION OF INTERNATIONAL HARVESTER OR IT’S SUCCESSORS. INTERNATIONAL HARVESTER AND IT’S SUCCESSORS
ARE NOT RESPONSIBLE FOR THE QUALITY OR ACCURACY OF THIS MANUAL.
TRADE MARKS AND TRADE NAMES CONTAINED AND USED HEREIN ARE THOSE OF OTHERS, AND ARE USED HERE IN A DESCRIPTIVE SENSE TO REFER TO THE PRODUCTS OF OTHERS.
582 Cub Cadet
IH-O-CC582
http://www.jensales.com/products/international-harvester-cub-cadet-582-lawn-garden-operators-manual.html
http://www.jensales.com/products/international-harvester-cub-cadet-582-lawn-garden-operators-manual.html
CONTENTS
TO THE OWNER Inside ELECTRICAL SYSTEM 19 to 21 Front Safety Starting Switch 19 Cover Charge Indicator 19
Seat Safety Switch 19 SERIAL NUMBERS 3 Hour Meter 19
Combination Lights INTRODUCTION 3 and Ignition Switch 19,20
Spark Plugs 20 WORK SAFELY - FOLLOW Fuses 20
THESE RULES 4,5,6 Battery 20,21
INSTRUMENTS AND CONTROLS 7 EQUIPMENT LIFT HANDLE 22
BEFORE OPERATING YOUR Height Adjustment 22 TRACTOR 8
HITCHING EQUIPMENT OPERATING THE TRACTOR 8 to 13 TO TH E TRACTOR 23
Throttle Lever 8 Drawbar 23 Governor 8 Three-Point Hitch (Optional) 23 Starting the Engine 8,9 Tractor Break-In FRONT POWER
Procedure 9 TAKE-OFF 23,24 Stopping the Engine 9 Operating the Front Cold Weather Starting 9 Power Take-Off Clutch 23 Operating in Cold Weather 10 Adjusting the Power Hood and Noise Isolation Take-Off Clutch 23,24
Panels 10 Adjusting the Seat 10, 11 CLUTCH- BRAKE 24,25 Clutch-Brake Pedal 11 Adjusting the Clutch 25 Locking the Brake 1 1 Adjusting the Brakes 25 Gearshift Lever 1 1 Driving the Tractor 11, 1 2 FRONT WHEELS 26 Driving on Slopes 12 Front Wheel Toe-In 26 Stopping the Tractor 12 Turning Radius 26 Creeper Shift Lever
(Optional) 13 PNEUMATIC TIRES 27,28 Operating the Creeper Inflation 27
Drive 13 Operating Pressure for Tires 27
ENGINE AND FUEL SYSTEM 14 to 17 Care of Tires 27 Engine Oil 15,16 Rear Wheel Weights Fuel Shut-Off Valve 16 (Optional) 27 Carburetor Adjustments 16,17 Mounting Tires on
the Rim 27 ENGINE COOLING AND Tire Chains (Optional) 28
AIR CLEANER 18 Overloading 28 Engine Cooling 18 Dry Type Air Cleaner with
Foam Pre-Cleaner Element 18
1
http://www.jensales.com/products/international-harvester-cub-cadet-582-lawn-garden-operators-manual.html
WORK SAFELY - FOLLOW THESE RULES
Look behind tractor before backing. Children may run up unnoticed behind a tractor.
Avoid overturns - Back the tractor up the steepest portion of the hill to be mowed! If the tractor cannot do this, the hill is too steep for safe operation. When mowing hills, cut up and down the face of the hill rather than across to avoid side tipping. Also,avoid sudden starts, stops, and turns, especially on steep slopes to avoid an upset.
Operate the tractor smoothly - avoid erratic operation and excessive speed. Always main-tain control. .
Reduce speed on slopes and in sharp turns to prevent tipping or loss of control. Always keep the tractor in gear when going down steep hills to take advantage of engine brak-ing action.
Stay alert for holes, rocks, tree stumps and other hazards in terrain which could cause an upset or loss of control which could result in injury.
Check overhead clearance carefully before driving under low hanging tree branches, or other situations where the operator may be struck or pulled from the tractor.
Watch out for traffic when near or crossing roadways.
Keep machine in good operating condition and keep safety devices in place.
Use guards or shields as instructed.
Stop machine and inspect for damage after striking an object. Repair any damage before restarting and operating machine because broken pieces could be thrown causing inju-ry.
5
Use care when pulling loads or using heavy equipment:
A. Use only approved hitch points. B. Limit loads to those you can safely
control. C. Don't turn too sharp, and use care
when backing. D. Use counterweight or wheel weights
when suggested in Operator's Manual.
Do not run the engine in confined areas such as storage buildings any longer than is nec-essary. Move the tractor outside into the air. EXHAUST GASES ARE TOXIC. OPENING DOORS AND WINDOWS MAY NOT PROVIDE ADEQUATE VENTILATION.
No one should operate the machine while intoxicated or while taking medication that impairs the senses or reactions.
TRANSPORTING
This tractor is not intended for use on public roads. If it must be transported use a pick up truck or suitable trailer.
Shut off power to attachments when transporting or not in use.
Be sure hitches and/or drawbars are properly stabilized before towing equipment to reduce possibility of loss of control and upset or col-lision.
http://www.jensales.com/products/international-harvester-cub-cadet-582-lawn-garden-operators-manual.html
INSTRUMENTS AND CONTROLS Your Cub Cadet Tractor has been safety engineered. Thoroughly acquaint yourself with al\ the instruments and controls before attempting to start or operate the tractor.
Instruments and controls - International Cub Cadet 582 Tractor
1. Creeper shift lever* 2. Fuses 3. Choke control 4. Brake pedal lock 5. Clutch and brake pedal 6. Charge Indicator 7. Hour meter
8. Front power take-off control switch
9. Throttle lever 10. Equipment lift handle 11. Ignition and light switch 1 2. Gear shift lever
*Optional Equipment
7
http://www.jensales.com/products/international-harvester-cub-cadet-582-lawn-garden-operators-manual.html
OPERATING THE TRACTOR
5. To start the engine, safety starting switches must be activated by pressing the clutch-brake pedal all the way down and moving the power take-off clutch switch to the disengaged position.
6. Check'to see that the gearshift lever is in the neutral position.
7. Turn the ignition key clockwise to the "START" position and release it as soon as the engine starts; however do not operate the starter for more than 30 seconds at anyone time. If the engine does not start within this time, turn the key "OFF" and wait a few minutes, then try again.
8. After the engine starts, slowly release the clutch-brake pedal and gradually push the choke control button all the way in. Do not use the choke to enrich the fuel mixture, except as necessary to start the engine.
TRACTOR BREAK-IN PROCEDURE
Never operate a new engine immediately under full load. Break it in carefully as shown in the table below.
Engine Throttle Control Lever
Period Position Load 1/2 3/4 Full
1 st hour X None X Light drawbar load
2nd hour I-- -- -- I-- -- -------or -- -- -X- Mowing withlractor at
slow speed X Medium drawbar load
3rd through -- -- >-- >--------1--- >-x
f,-,. __ or ____ 13th hour Normal mowing
STOPPING THE ENGINE
Move the throttle lever to the "SLOW" posi-tion and allow the engine to idle for a short time before stopping. Then turn the key to the "OFF" position.
9
COLD WEATHER STARTING
To start engine in cold weather use correct weight of oil, be sure battery is fully charged, and the proper starting procedure is followed. The best procedure for starting at tem-peratures near or below freezing is as follows:
1. Pull the choke all the way out into the full choke position. 2. Move the throttle lever just off slow posi-tion.
3. Press the clutch-brake pedal all the way down and be sure the power take-off switch is in the off position. The safety interlocks will prevent starting unless this is done.
4. Move the key switch into the start position and hold until the engine starts; however, do not operate the starter for more than 30 seconds at anyone time. As soon as the engine starts, slowly push the choke in part way.
A CAUTION! During operation do not run the engine in confined area such as storage building any longer than is necessary. Immediately move the tractor outside into the air.
NOTE: In cold weather the starting motor may disengage prematurely. This is caused by the engine firing once but failing to continue run-ning. If this happens several times, the engine will be flooded and it will be necessary to start as described in Step 5.
5. Leave the throttle in the slow position but push the choke in all the way; then turn the ignition key to the start position and slowly pull the choke out to the pOSition which will cause the engine to start and continue run-ning. If the engine falters after shifting into motion, pull the choke out part way until the engine runs smoothly, then gradually push the choke back in as the engine warms,
http://www.jensales.com/products/international-harvester-cub-cadet-582-lawn-garden-operators-manual.html
OPERATING THE TRACTOR
Always be sure the rear wheels are free to turn. Under any adverse conditions, do not atte.mpt to free the tractor by speeding up the engl~e and s.uddenly engaging the clutch. Try backing out Instead of gOing forward.
A CAUTION! Do not leave the seat of . the tractor without disengaging the brake pedal and setting the
brake lock. If leaving the tractor unat-tended, also turn the ignition key off and remove the key.
Seat Safety Switch
When using power take-off operated equip-ment, the operator must remain in tractor seat at all times. If operator should leave tractor seat without turning off the power take-off switch, the engine will automatically shut off.
DRIVING ON SLOPES
Before operating the tractor on any slope, 'valk the slope to look for possible hazards such as rocks, mounds, ruts, stumps or other surface irregularities which could cause an upset.
Back the tractor with implement up the steepest portion of each slope you intend to ~ork. If the tractor can not negotiate the slope In reverse, the slope is too steep to be worked.
A CAUTION! Always drive up or down the face of a slope. Do not drive so that the tractor may tip
over sideways.
12
Avoid turns when driving on a slope. If a turn must be made, turn down the slope. Turning up a slope greatly increases the chance of a roll over.
Avoid stopping when driving up a slope. If it is necessary to stop while driving up a slope, start up smoothly and carefully to reduce the possibility of flipping the tractor over back-ward.
STOPPING THE TRACTOR
Disengage the clutch by pressing the pedal all the way down. Move the gearshift lever to the "N" position.
Q\_, A CAUTION! .Always engage park, lower equipment and shut-off
engine before dismounting. Never start engine from ground.
MA-16882
http://www.jensales.com/products/international-harvester-cub-cadet-582-lawn-garden-operators-manual.html
Recommended