Upload
dufferrahul
View
4.641
Download
4
Tags:
Embed Size (px)
DESCRIPTION
biogas plant
Citation preview
Presentation on biogas plant with some facts
Presented by:-
Shashank mathur
4-BT-42
Btech biotech
IV SEM.
JAIPUR NATIONAL UNIVERSITY
The contents are :-• Introduction• Objectives• Researches • Charts• Tables • References
Introduction :-
Biogas plants may be classified in several ways depending upon the plant design and mode of working. In India are popularly known as the conventional type and Deenbandhu model.
Digesters can also be vertical and horizontal displacement types depending on the orientation of digester.
The horizontal plants are suited for high groundwater level or rocky areas.
Deenbandhu is a low cost fixed dome biogas plant model. Substrates must be degradable. Substrates should have a nearly constant composition. Concentration of organic dry matter should be higher than 2 %. Substrates should be a liquid slurry. Digester volume should be more than about 100m3.
Objectives :-
The waste disposal is a global environmental problem. Energy from waste as an alternative to fossil fuels
provides an important contribution towards the reduction in landfill disposal and global warming.
Energy recovery from waste provides a double environmental benefit. Firstly, the diversion of waste from landfill.
secondly, the recovery of energy, displacing fossil fuel alternatives and reducing greenhouse gas emissions. To tackle climate change, there is an urgent need to reduce energy use by adopting more efficient technologies and to generate from sources that release much less or no carbon dioxide causing global warming.
Researches done by scientists:-
Chandra (2007):Discussed distributed energy systems based on renewable energy resources like solar, wind, hydro and bio-waste and compared on the basis of energy pay back time.
Chani et al(2003): Embodied energy of building materials in India had been presented.
•VENKATARAMA REDDY (2004) :- He described a brief history of building materials, energy consumption in manufacture and transportation of some common and alternative building materials and the implication on environment.
•DAS AND KANDPAL (1997):- Comparative analysis were also carried out to gauge the energy efficiency of the walling elements and to identify the most suitable option.
Methodology:-
Equations: Embodied energy= m e where, m=Quantity of materials used in constructing biogas plants
in kg. e=energy density of the material in MJ/kg.
Table: Energy density of materials used in plants:-
Materials Embododied energy
Brick 1.8
Cement 6.7
Stone chips 0.08
Sand 0.08
Coarse sand 0.08
Iron bar 29.06
Steel 32
PVC pipe 49.97
½” G.I. pipe 11.83
Initial cost = Z C
where, Z : Quantity of materials. C : unit cost of materials in Indian currency.
Net energy output =HV.S.G.
Where,
HV= heating value of fuel, in MJ/m3
S= Capacity of biogas plant in m3
G = Gas production per day in m3 per biogas plant capacity.
Money pay back time in years (MPBT) = Input cost / running cost per unit time
Energy pay back time (EPBT)= Embodied energy/Energy output
Serial no: Plant size(m3)
Net energy (MJ/day)
Horizontal type
Biogas plant
Vertical type
Biogas plant
Embodied energy (MJ)
EPBT
(years)
Embodied
Energy
(MJ)
EPBT
(years)
1. 2.83 31.125 31939.4 2.809 26412.914 2.323
2. 4.25 46.75 37471.1 2.196 31122.914 1.824
3. 7.08 77.88 45452.6 1.599 38374.094 1.350
4. 14.02 154.22 86585.8 1.538 74734.202 1.330
Embodied energy, net energy output and EPBT for different models and plants size
Input cost and MPBT for different models and plants size.
Serial no: Plant size(m3)
Horizontal type
Biogas plant
Vertical type
Biogas plant
Input cost
(rs.)
MPBT
(years)
Input cost
(rs.)
MPBT
(years)
1. 2.83 31939.4 1.80 29810 1.54
2. 4.25 37471.1 1.55 39655 1.36
3. 7.08 45452.6 1.12 48535 0.99
4. 14.02 86585.8 0.91 76998 0.80
CONCLUSION:-
•EPBT decreases as the biogas plant size increases .
•MPBT also decreases in same manner with increase the plants size of the models.
Some snap shots of the area around a biogas plant
References:-
• Mathur J., 1998,Energy and Emission Analysis of Selected Energy Systems in India, Master of Technology Thesis, Centre for Energy Studies, Indian Institute of Technology, Delhi, India •TERI, 1994, Biogas: A source of Rural Employment, Tata Energy Research Institute, New Delhi, 36.Tiwari, G.N., and Ghosal, M.K., •2005,Renewable Energy Resources: Basic Principles and Applications, Narosa TERI, 1982, Source: Punjab Agricultural University, Ludhiana, 38. •Google searches…