Sony Vpl Cs1

...............

WORLD

SERVICE MANUALDEST...........

VPL-CS1

R

LCD VIDEO PROJECTOR

...............MODEL

RM-PJM1

MODEL DEST...........

WORLD

WARNING!!

AN INSULATED TRANSFORMER SHOULD BE USED DURINGANY SERVICE TO AVOID POSSIBLE SHOCK HAZARD, BE-CAUSE OF LIVE CHASSIS.THE CHASSIS OF THIS RECEIVER IS DIRECTLY CONNECTEDTO THE AC POWER LINE.

SAFETY-RELATED COMPONENT WARNING !!

COMPONENTS IDENTIFIED BY A ! MARK ON THE SCHEMATICDIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARECRITICAL TO SAFE OPERATION. REPLACE THESE COMPO-NENTS WITH SONY PARTS WHOSE PART NUMBERS APPEARAS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUB-LISHED BY SONY.

ATTENTION!!

AFIN D’ÉVITER TOUT RISQUE D’ÉLECTROCUTIONPROVENANT D’UN CHÂSSIS SOUS TENSION, UNTRANSFORMATEUR D’ISOLEMENT DOIT ETRE UTILISÉ LORSDE TOUT DÉPANNAGE.LE CHÂSSIS DE CE RÉCEPTEUR EST DIRECTEMENTRACCORDÉ Á L’ALIMENTATION SECTEUR.

ATTENTION AUX COMPOSANTS RELATIFS Á LASÉCURITÉ!!

LES COMPOSANTS IDENTIFIÉS PAR UNE MAPQUE ! SURLES SCHÉMAS DE PRINCIPE, LES VUES EXPLOSÉES ET LESLISTES DE PIECES SONT D’UNE IMPORTANCE CRITIQUEPOUR LA SÉCURITÉ DU FONCTIONNEMENT. NE LESREMPLACER QUE PAR DES COMPOSANTS SONY DONT LENUMÉRO DE PIÈCE EST INDIQUÉ DANS LE PRÉSENT MANUELOU DANS DES SUPPLÉMENTS PUBLIÉS PAR SONY.

! WARNINGThis manual is intended for qualified service personnel only.To reduce the risk of electric shock, fire or injury, do not perform any servicing other than thatcontained in the operating instructions unless you are qualified to do so. Refer all servicing toqualified service personnel.

! WARNUNGDie Anleitung ist nur für qualifiziertes Fachpersonal bestimmt.Alle Wartungsarbeiten dürfen nur von qualifiziertem Fachpersonal ausgeführt werden. Um dieGefahr eines elektrischen Schlages, Feuergefahr und Verletzungen zu vermeiden, sind beiWartungsarbeiten strikt die Angaben in der Anleitung zu befolgen. Andere als die angegebenWartungsarbeiten dürfen nur von Personen ausgeführt werden, die eine spezielle Befähigungdazu besitzen.

! AVERTISSEMENTCe manual est destiné uniquement aux personnes compétentes en charge de l’entretien. Afinde réduire les risques de décharge électrique, d’incendie ou de blessure n’effectuer que lesréparations indiquées dans le mode d’emploi à moins d’être qualifié pour en effectuer d’autres.Pour toute réparation faire appel à une personne compétente uniquement.

1VPL-CS1

TABLE OF CONTENTS

1. Operating Instructions

Operating Instructions ............................................................................................ 1-1

Quick Reference Card .......................................................................................... 1-22

2. Service Informations

2-1. Circuit Boards Location .............................................................................. 2-1

2-2. Extension Boards and Flexible Cables ........................................................ 2-1

2-3. Cover Removal............................................................................................ 2-2

2-4. Front Panel Assy and NF Board Removal .................................................. 2-2

2-5. C Board Removal ........................................................................................ 2-3

2-6. Optics Unit Assy Removal .......................................................................... 2-3

2-7. GA, GBA and GBB Boards Removal ......................................................... 2-4

2-8. B, BA and QA Boards Removal ................................................................. 2-4

2-9. Lens Removal.............................................................................................. 2-5

2-10. Prism Block and In-Polarizer Panel Assy Removal .................................... 2-5

3. Electrical Adjustments

3-1. Preparations ................................................................................................. 3-13-1-1. Equipment Required................................................................... 3-13-1-2. Optical Unit Adjustment ............................................................ 3-1

3-1-2-1. Mirror Adjustment ....................................................... 3-13-1-2-2. Polarizing Plate Adjustment ......................................... 3-1

3-1-3. Factory Mode Setting ................................................................. 3-1

3-2 V-COM Adjustment .................................................................................... 3-1

3-3. Adjustment Item Initialize Data .................................................................. 3-2

3-4. Service Kowhow ......................................................................................... 3-53-4-1. After Replacing the Prism Block ............................................... 3-53-4-2. After Replacing the Board ......................................................... 3-5

3-4-2-1. When Replacing the BA Board .................................... 3-53-4-2-2. When Replacing the C Board ....................................... 3-53-4-2-3. When Replacing the Other Board ................................ 3-5

3-5. White Balance Adjustment on Servicing .................................................... 3-63-5-1. Signal Level Adjustment ............................................................ 3-63-5-2. White Balance Adjustment ........................................................ 3-6

3-5-2-1. HIGH Mode of INPUT-A ............................................ 3-63-5-2-2. LOW Mode of INPUT-A ............................................. 3-63-5-2-3. HIGH Mode of VIDEO................................................ 3-63-5-2-4. LOW Mode of VIDEO................................................. 3-6

3-6. Memory ....................................................................................................... 3-7

2 VPL-CS1

4. Semiconductors

5. Exploded Views

5-1. Cover ........................................................................................................... 5-1

5-2. Chassis ......................................................................................................... 5-2

5-3. Base ............................................................................................................. 5-3

5-4. Optics (1/2) .................................................................................................. 5-4

5-5. Optics (2/2) .................................................................................................. 5-5

6. Electrical Parts List

7. Block Diagrams

Overall .................................................................................................................... 7-1

NF, QA ................................................................................................................... 7-2

BA........................................................................................................................... 7-3

B ............................................................................................................................. 7-4

C, H......................................................................................................................... 7-6

GA, GAB, GBB ...................................................................................................... 7-8

8. Diagrams

8-1. Frame Schematic DiagramFrame (1/2) ............................................................................................... 8-1Frame (2/2) ............................................................................................... 8-2

8-2. Schematic Diagrams and Printed Wiring Boards ........................................ 8-3

Schematic DiagramsNF, QA (1/2) ............................................................................................. 8-5QA (2/2) .................................................................................................... 8-6BA ............................................................................................................. 8-8B (1/4) ..................................................................................................... 8-10B (2/4) ..................................................................................................... 8-11B (3/4) ..................................................................................................... 8-12B (4/4) ..................................................................................................... 8-13C (1/5) .................................................................................................. 8-15C (2/5) .................................................................................................. 8-16C (3/5) .................................................................................................. 8-17C (4/5) .................................................................................................. 8-18C (5/5) .................................................................................................. 8-19H.............................................................................................................. 8-21GA ........................................................................................................... 8-23

3VPL-CS1

GBA ........................................................................................................ 8-24GBB ........................................................................................................ 8-24

Printed Wiring BoardsNF, QA...................................................................................................... 8-4BA ............................................................................................................. 8-7B ................................................................................................................ 8-9C .............................................................................................................. 8-14H.............................................................................................................. 8-21GA ........................................................................................................... 8-22GBA ........................................................................................................ 8-24GBB ........................................................................................................ 8-24

1-1V

PL-C

S1

Section 1

Operating Instructions

This section is extracted

from operation m

anual.

Operating Instructions

Mode d'emploi

Manual de instrucciones

© 1999 Sony Corporation

4-074-278-11 (1)

LCD Data Projector

GB

FR

ES

VPL-CS1

1-2V

PL-C

S1

GB 2

WARNING

To prevent fire or shock hazard, do not expose the unit to rain or moisture.

To avoid electrical shock, do not open the cabinet. Refer servicing to qualified personnel only.

For the customers in the USA

Declaration of ConformityTrade Name: SONYModel No.: VPL-CS1Responsible Party: Sony Electronics Inc.Address: 1 Sony Drive, Park Ridge, NJ.07656 USATelephone No.: 201-930-6970

This device complies with Part 15 of the FCC Rules. Operation is subject to the

following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, including interference that may cause undesired operation.

This equipment has been tested and found to comply with the limits for a Class B digital device, pursuant to Part 15 of the FCC Rules. These limits are designed to provide reasonable protection against harmful interference in a residential installation. This equipment generates, uses, and can radiate radio frequency energy and, if not installed and used in accordance with the instructions, may cause harmful interference to radio communications. However, there is no guarantee that interference will not occur in a particular installation. If this equipment does cause harmful interference to radio or television reception, which can be determined by turning the equipment off and on, the user is encouraged to try to correct the interference by one or more of the following measures:- Reorient or relocate the receiving antenna.- Increase the separation between the

equipment and receiver.- Connect the equipment into an outlet on a

circuit different from that to which the receiver is connected.

- Consult the dealer or an experienced radio/TV technician for help.

You are cautioned that any changes or modifications not expressly approved in this manual could void your authority to operate this equipment.

For the customers in CanadaThis Class B digital apparatus complies with Canadian ICES-003.

This symbol is intended to alert the user to the presence of uninsulated “dangerous voltage” within the product’s enclosure that may be of sufficient magnitude to constitute a risk of electric shock to persons.

This symbol is intended to alert the user to the presence of important operating and maintenance (servicing) instructions in the literature accompanying the appliance.

3 GB

For the customers in the United Kingdom

WARNING

THIS APPARATUS MUST BE EARTHED

IMPORTANTThe wires in this mains lead are coloured in accordance with the following code:Green-and-Yellow: EarthBlue: NeutralBrown: LiveAs the colours of the wires in the mains lead of this apparatus may not correspond with the coloured markings identifying the terminals in your plug proceed as follows:The wire which is coloured green-and-yellow must be connected to the terminal in the plug which is marked by the letter E or by the safety earth symbol I or coloured green or green-and-yellow.The wire which is coloured blue must be connected to the terminal which is marked with the letter N or coloured black. The wire which is coloured brown must be connected to the terminal which is marked with the letter L or coloured red.

Voor de klanten in Nederland

Bij dit product zijn batterijen geleverd. Wanneer deze leeg zijn, moet u ze niet weggooien maar inleveren als KCA.

The socket-outlet should be installed near the equipment and be easily accessible.

1-3V

PL-C

S1

5 GB

Table of Contents

Overview

Precautions .........................................6

Features ..............................................7

Location and Function of Controls ...8

Front/Left Side/Bottom ................8

Rear/Right Side ............................8

Control Panel ..............................10

Connector Panel .........................11

Remote Commander ...................12

Setting Up and Projecting

Installing the Projector .....................14

Connecting the Projector ..................15

Connecting with a Computer ......15

Connecting with a VCR or 15k RGB/ComponentEquipment .......................17

Selecting the Menu Language ..........19

Projecting .........................................21

Adjustments and Settings Using the Menu

Using the MENU .............................24

The PICTURE CTRL Menu ............25

The INPUT SETTING Menu ...........26

The SET SETTING Menu ...............27

Maintenance

Maintenance .....................................29

Replacing the Lamp ....................29

Cleaning the Air Filter ................30

Troubleshooting ...............................31

Warning Messages .....................33

Caution Messages ......................33

Other

Notes on Installation ........................34

Unsuitable Installation ...............34

Unsuitable Conditions ................34

Specifications ..................................35

Index ...............................................41

GB

1-4V

PL-C

S1

GB 6 Precautions

B Overview

Precautions

On safety• Check that the operating voltage of your

unit is identical with the voltage of your local power supply.

• Should any liquid or solid object fall into the cabinet, unplug the unit and have it checked by qualified personnel before operating it further.

• Unplug the unit from the wall outlet if it is not to be used for several days.

• To disconnect the cord, pull it out by the plug. Never pull the cord itself.

• The wall outlet should be near the unit and easily accessible.

• The unit is not disconnected to the AC power source (mains) as long as it is connected to the wall outlet, even if the unit itself has been turned off.

• Do not look into the lens while the lamp is on.

• Do not place your hand or objects near the ventilation holes. The air coming out is hot.

• Be careful not to catch your fingers by the adjuster when you lift up the projector. Do not push hard on the top of the projector with the adjuster out.

On illumination• To obtain the best picture, the front of the

screen should not be exposed to direct lighting or sunlight.

• Ceiling-mounted spot lighting is recommended. Use a cover over fluorescent lamps to avoid lowering the contrast ratio.

• Cover any windows that face the screen with opaque draperies.

• It is desirable to install the projector in a room where floor and walls are not of light-reflecting material. If the floor and walls are of reflecting material, it is recommended that the carpet and wall paper be changed to a dark color.

On preventing internal heat build-up After you turn off the power with the I / 1 key, do not disconnect the unit from the wall outlet while the cooling fan is still running.

CautionThe projector is equipped with ventilation holes (intake) on the bottom side and ventilation holes (exhaust) on left and rear. Do not block or place anything near these holes, or internal heat build-up may occur, causing picture degradation or damage to the projector.

On cleaning• To keep the cabinet looking new,

periodically clean it with a soft cloth. Stubborn stains may be removed with a cloth lightly dampened with a mild detergent solution. Never use strong solvents, such as thinner, benzene, or abrasive cleansers, since these will damage the cabinet.

• Avoid touching the lens. To remove dust on the lens, use a soft dry cloth. Do not use a damp cloth, detergent solution, or thinner.

• Clean the filter at regular intervals.

On repacking• Save the original shipping carton and

packing material; they will come in handy if you ever have to ship your unit. For maximum protection, repack your unit as it was originally packed at the factory.

7 GBFeatures

Overview

Features

High portability• Light weight/small size

This projector has been miniaturized to approx. 2.9 kg (6 lb 6 oz) in weight and B5-file size through the adoption of a new retractable mechanism. A carrying handle and a removable strap are equipped with the projector, so you can carry it easily with your computer.

Reduced noiseBecause the projector uses a new cooling mechanism, noise has been reduced.

High brightness, high picture quality• High brightness

Adopting the new developed optical system and the 120 W UHP lamp allows high brightness (light output 600 ANSI lumen) and excellent uniformity on the picture.

• High resolutionThree 0.7-inch, about 480,000 pixel SVGA panels provide a resolution of 800 × 600 dots for RGB input and 600 horizontal TV lines for video input.

Simple setup, easy presentation• Simple setup with external equipment

This projector is preset for 37 kinds of input signals. You can project images from an external signal source just by connecting the equipment with the supplied cable and pushing the APA key.

• Simple Remote Commander with mouse control functionsYou can operate a computer with the Remote Commander since the unit has a build-in mouse receiver.

Compatible with USB (Universal Serial Bus) hub functionYou can connect the projector to USB equipment, such as a USB mouse, and

control the projector by using the supplied application software from a computer.1)

Using this application software, you can open a file you want to use for your presentation with the supplied Remote Commander.

Accepts various input signals• Scan converter loaded

This projector has a build-in scan converter that converts the input signal within 800 × 600 dots.

• Compatible input signalsThis projector accepts video signals of composite, S video, and component as well as 15k RGB, VGA, SVGA, XGA, and SXGA signals, which all can be displayed.

• Compatible with six color systemsNTSC, PAL, SECAM, NTSC4.43

2), PAL-M, or PAL-N color system can be selected automatically or manually.

......................................................................

• Windows is a registered trademark of Microsoft Corporation in the United States and/or other countries.

• VGA, SVGA, XGA, and SXGA are registered trademarks of the International Business Machines Corporation, U.S.A.

• Macintosh is a registered trademark of Apple Computer, Inc.

• IBM PC/AT is a registered trademark of International Business Machines Corporation, U.S.A.

• VESA is a registered trademark of Video Electronics Standard Association.

• Display Data Channel is a trademark of Video Electronics Standard Association.

• PC-98 is a trademark of NEC Corporation.

1)The supplied application software and the USB hub function of this projector are compatible with Windows 98 preinstall model.

2)NTSC4.43 is the color system used when playing back a video recorded on NTSC on a NTSC4.43 system VCR.

1-5V

PL-C

S1

GB 8 Location and Function of Controls

Location and Function of Controls

1 Lock button

2 Front coverSlide the lock button to open the front cover. The leg on the bottom of the projector opens. When projecting the picture, place the projector on a flat surface with the leg open.

3 Carrying handlePull up the handle from the projector for carrying.

4 Zoom ringAdjusts the picture size.

5 Focus ringAdjusts the picture focus.

6 Front remote control detector (SIRCS receiver)

7 Lens

8 AC IN socketConnects the supplied AC power cord.

9 Ventilation holes (intake)/air filter cover (bottom)

• Do not place anything near the ventilation holes as it may cause internal heat build-up.

• Do not place your hand or objects near the ventilation holes as it may cause the air coming out heat build-up.

• To maintain optimal performance, clean the air filter every 300 hours.

q;q;q;q; Lamp cover (bottom)

qaqaqaqa Ventilation holes (exhaust)

qsqsqsqs Control panelFor details, see “Control Panel” on page 10.

qdqdqdqd Shoulder strap holder

Front/Left Side/Bottom

Rear/Right Side

Notes

9 GBLocation and Function of Controls

Overview

qqqqffff Security lockConnects to an optional security cable (Kensington’s).

qqqqgggg Speaker

qqqqhhhh Rear remote control detector (SIRCS receiver)

qqqqjjjj Leg

qqqqkkkk Connector panelFor details, see “Connector Panel” on page 11.

qqqqllll Ventilation holes (intake)

The security lock corresponds to Kensington’s MicroSaver Security System.If you have any comment, contact:

Kensington2853 Campus DriveSan Mates, CA 94403 U.S.A.Tel: 800-535-4242: extension 3348

Home page address: http://www.kensington.com/

1-6V

PL-C

S1


1 I / 1111 (on/standby) keyTurns on and off the projector when the projector is in standby mode. The ON/STANDBY indicator lights in green when the power is turned on.When turning off the power, press the I / 1 key twice following the message on the screen, or press and hold the key for about one second.

For details on steps for turning off the power, see “To turn off the power” on page 23.

2 INPUT keySelects the input signal. Each time you press the key, the input signal switches between video input and INPUT A connector.

3 APA (Auto Pixel Alignment) keyAdjusts a picture clearest automatically while a signal is input from a computer.

4 VOLUME +/– keysAdjust the volume of the built-in speakers.

+ : Increases the volume.

– : Decreases the volume.

5 Indicators• LAMP/COVER: Lights up or flashes

under the following conditions:– Lights up when the lamp has

reached the end of its life or becomes a high temperature.

– Flashes when the lamp cover or air filter cover is not secured firmly.

• FAN/TEMP (Temperature): Lights up or flashes under the following conditions:– Lights up when temperature inside

the projector becomes unusually high.

– Flashes when the fan is broken.• POWER SAVING: Lights up when

the projector is in power saving mode. When POWER SAVING in the SET SETTING menu is set to ON, the projector goes into power saving mode if no signal is input for 10 minutes. Although the lamp goes out, the cooling fan keeps running. In power saving mode, any key does not function for the first 30 seconds. The power saving mode is canceled when a signal is input or any key is pressed.

• ON/STANDBY: Lights up or flashes under the following conditions:– Lights in red when a AC power cord

is plugged into a wall outlet. Once in standby mode, you can turn on the projector with the I / 1 key.

– Lights in green when the power is turned on.

– Flashes in green while the cooling fan runs after the power is turned off with the I / 1 key. The fan runs for about 90 seconds after the power is turned off.The ON/STANDBY indicator flashes quickly for the first 30 seconds. During this time, you cannot turn the power back on with the I / 1 key.

For details on the LAMP/COVER and the FAN/TEMP indicators, see page 32.

Control Panel

RESET MENU POWER

INPUT

APA

VOLUME

POWER SAVING ON/STANDBYFAN/TEMP

LAMP/COVER

ENTER

+–


Overview

6 ENTER keyEnters the settings of items in the menu system.

7 Arrow keys ( MMMM/mmmm/<<<</,,,,)Select the menu or to make various adjustments.

8 RESET keyResets the value of an item back to its factory preset value. This key functions when the menu or a setting item is displayed on the screen.

9 MENU keyDisplays the on-screen menu. Press again to clear the menu.

1 INPUT A connector (HD D-sub 15-pin, female)Connect to external equipment such as a computer. Connects to the monitor output on a computer using the supplied cable. When inputting a component or 15k RGB signal, use an optional cable.

2 Video input connectorConnect to external video equipment such as a VCR.• S VIDEO (mini DIN 4-pin):

Connects to the S video output (Y/C video output) of video equipment.

• VIDEO (phono type): Connects to the composite video output of video equipment.

If you connect video equipment to both the S VIDEO and VIDEO jacks, the signal from the S VIDEO jack is selected. When projecting the picture via the VIDEO jack, be sure not to connect a cable to the S VIDEO jack.

3 MOUSE connector (6-pin) Connects to the PS/2 mouse port on a computer via the supplied mouse cable, to control the mouse function of the connected computer.

4 USB connector (USB A-plug for downstream, 4-pin)Connect to USB equipment such as a mouse, camera, etc.

5 USB connector (USB B-plug for upstream, 4-pin)Connect to the USB connector on a computer. When you connect the projector to the computer, the projector recognizes the mouse of the computer connected to the INPUT A connector and you can control the mouse function with the supplied Remote Commander. The supplied application software can be installed in the computer attached to this connector.

6 AUDIO (stereo minijack) connectorWhen listening to sound output from the computer, connect to the audio output of the computer. When listening to sound output from the VCR, connect to the audio output of the VCR.This connector functions as the audio input of the INPUT A, VIDEO and S VIDEO connectors.

Connector Panel

INPUT AS VIDEOVIDEOMOUSEAUDIO

Rear side

Note

1-7V

PL-C

S1


The keys that have the same names as those on the control panel function identically.You can control a connected computer using the Remote Commander.

For details, see “To control the computer using the supplied Remote Commander” on page 22.

1 I / 1111 key

2 INPUT key

3 FUNCTION 1, 2 keysWhen you have saved a file in the FUNCTION 1 or 2 key using the supplied application software, you can open the file with a press of the corresponding key.

For details, see the README file and the HELP file supplied with the application software.

4 L CLICK keyFunctions as the left button on a mouse.

5 R CLICK keyFunctions as the right button on a mouse.

6 JoystickFunctions as the mouse of the computer connected to the unit.

7 Infrared transmitter

To install batteries

1 Push and slide to open the lid, then install the two size AAA (R03) batteries (supplied) with the correct polarity.

2 Replace the lid.

Remote Commander

INPUT

R. CLICK

FUNCTION

1

2

Be sure to install the battery from the # side.


Overview

Notes on batteries• Make sure that the battery orientation is

correct when inserting batteries.• Do not mix an old battery with a new one

or different types of batteries. • If you do not use the Remote Commander

for a long time, remove the batteries to avoid damage from battery leakage. If batteries have leaked, remove them, wipe and dry the battery compartment, and replace the batteries with new ones.

Notes on Remote Commander operation• Make sure that nothing obstructs the

infrared beam between the Remote Commander and the remote control detector on the projector. Direct the Remote Commander toward the front or rear remote control detector.

• The operation range is limited. The shorter the distance between the Remote Commander and the projector is, the wider the angle within which the commander can control the projector becomes.

1-8V

PL-C

S1

GB 14 Installing the Projector

g p j g

Installing the ProjectorThis section describes how to install the projector.The distance between the lens and the screen varies depending on the size of the screen. Use the following table as a guide.

You can not install the projector upside down, such as on a ceiling.

Unit: m (feet)

Screen size (inches)

40 60 80 100 120 150

Minimum Distance

1.6 (5.2)

2.4 (7.8)

3.2 (10.5)

4.0 (13.2)

4.9(15.9)

6.1 (20.0)

Maximum Distance

2.0 (6.6)

3.1(10.0)

4.1 (13.5)

5.2 (16.9)

6.2(20.3)

7.8(25.5)

Note

��

Distance between the screen and the center of the lens

15 GBConnecting the Projector

Setting U

p and Projecting

Connecting the ProjectorWhen making connections, be sure to do the following:

• Turn off all equipment before making any connections.• Use the proper cables for each connection.• Insert the cable plugs properly; plugs that are not fully inserted often

generate noise. When pulling out a cable, be sure to pull it out from the plug, not the cable itself.

Supplied mouse cables may not work properly according to your computer.

This section describes how to connect the projector to a computer.For more information, refer to the computer’s instruction manual.

• The projector accepts VGA, SVGA, XGA, and SXGA signals. However, we recommend that you set the output mode of your computer to SVGA mode for the external monitor.

• If you set your computer, such as a notebook type, to output the signal to both your computer’s display and the external monitor, the picture of the external monitor may not appear properly. Set your computer to output the signal to only the external monitor.For details, refer to the computer’s operating instructions supplied with your computer.

• Supplied mouse cables may not work properly according to your computer.• This projector is compatible with a DDC2B (Digital Data Channel 2B). If your

computer is compatible with a DDC, turn the projector on according to the following procedures.

1 Connect the projector to the computer by using the supplied HD D-sub 15 pin cable.2 Turn the projector on.3 Start the computer.

Note

Connecting with a Computer

Notes

1-9V

PL-C

S1

GB 16 Connecting the Projector

To connect an IBM PC/AT compatible computer

When you use a USB mouse and USB equipment

• When you use the supplied application software, connect your computer as illustrated above. This application software and the USB hub function can be used on a computer loaded with Windows 98 preinstall model.

• As the projector recognizes the USB mouse when the computer is connected to the USB connector, do not connect anything to the PS/2 mouse port.

• Your computer may not start correctly when it has been connected to the USB connector on the projector via the USB cable. In this case, first disconnect the USB cable, restart the computer, then connect the computer to the projector using the USB cable supplied with the projector.

On the USB hub functionWhen connecting the projector to a computer by using the USB cable for the first time, the computer recognizes the following devices automatically.

1 USB hub (general use)2 USB human interface device (wireless mouse function)3 USB human interface device (projector control function)

Excepting these devices above mentioned, the computer recognizes the device connected to the downstream connector on the projector.

Notes


Rear side

USB equipment

USB cable A type – B type (supplied)

Stereo audio connecting cable (not supplied)

HD D-sub 15-pin cable (supplied)

to USB connector

to monitor output

to audio output

Computer

17 GBConnecting the Projector

Setting U

p and Projecting

When you use a PS/2 mouse port

To connect a Macintosh computer Use an ADP-20 signal adapter (not supplied). In this case, however, you can not control the mouse of the computer by the Remote Commander.

This section describes how to connect the projector to a VCR and 15k RGB/component equipment. For more information, refer to the instruction manuals of the equipment you are connecting.

To connect a VCR

1)When both the S VIDEO and VIDEO jacks are connected to the external equipment, the input signal from the S VIDEO jack is selected.

Connecting with a VCR or 15k RGB/ Component Equipment


to audio output

Rear side

HD D-sub 15-pin cable (supplied)

to mouse port (PS/2)PS/2 Mouse cable (supplied)


to monitor output

Computer


Video cable (not supplied)


S-Video cable (not supplied)

VCR

to video output1)

to S video output1)

Rear side

to audio output

1-10V

PL-C

S1

GB 18 Connecting the Projector

To connect a 15k RGB/Component equipment

• Set the aspect ratio using ASPECT in the INPUT SETTING menu according to the input signal.

• When you connect the unit to 15k RGB/component video equipment, select RGB or component with the INPUT-A setting in the SET SETTING menu.

• Use the composite sync signal when you input the external sync signal from 15k RGB/component equipment.

Notes


Rear side


SMF-402 Signal Cable (not supplied) 3 × phono jack ↔ HD D-sub 15-pin (male)

to audio output

15k RGB/Component equipment

to RGB/component output

19 GBSelecting the Menu Language

Setting U

p and Projecting

Selecting the Menu LanguageYou can select one of seven languages for displaying the menu and other on-screen displays. The factory setting is English.

1 Open the front cover, then plug the AC power cord into a wall outlet.

2 Press the I / 1 key to turn on the projector.

3 Press the MENU key.The menu appears.The menu presently selected is shown as a yellow button.

1

RESET MENU POWER

INPUT

APA

VOLUME


LAMP/COVER

ENTER

3 2

4,5,6+–

8 0

5 0

PICTURE CTRL

CONTRAST:

BRIGHT:

GAMMA MODE: GRAPHICS

COLOR TEMP: HIGH

INPUT-A

1-11V

PL-C

S1

GB 20 Selecting the Menu Language

4 Press the M or m key to select the SET SETTING menu, then press the , or ENTER key.The selected menu appears.

5 Press the M or m key to select “LANGUAGE,” then press the , or ENTER key.

6 Press the M or m key to select a language, then press the < or ENTER key.The menu changes to the selected language.

To clear the menuPress the MENU key.The menu disappears automatically if a key is not pressed for one minute.

SET SETTING

STATUS: ON

INPUT-A: RGB

KEYSTONE MEMORY: OFF

DIGITAL KEYSTONE: OFF

LANGUAGE: ENGLISH

POWER SAVING: OFF

SIRCS RECEIVER: FRONT&REAR

LAMP TIMER: 00010h

INPUT-A

SET SETTING

STATUS: ON

INPUT-A: RGB



LANGUAGE: ENGLISH

POWER SAVING: OFF


LAMP TIMER: 00010h

INPUT-A

21 GBProjecting

Setting U

p and Projecting

Projecting

1 Open the front cover, plug the AC power cord into a wall outlet, then connect all equipment.The ON/STANDBY indicator lights in red and the projector goes into standby mode.

2 Press the I / 1 key.The ON/STANDBY indicator lights in green.

3 Turn on the equipment connected to the projector.

4 Press the INPUT key to select the input source.

1) If you connect to both the S VIDEO and VIDEO jacks, the signal from the S VIDEO jack is selected.

To input from Press INPUT to display

Computer connected to the INPUT A connector INPUT A

Video equipment connected to the video1) input connector

VIDEO

RESET MENU POWER

INPUT

APA


LAMP/COVER

ENTER

VOLUME

INPUTFUNCTION

1

2

R.CLICK

1

56

24

24

Rear remote control detector

ON/STANDBY indicator

APA key

VOLUME +/– keys

1-12V

PL-C

S1

GB 22 Projecting

5 Turn the zoom ring to adjust the size of the picture.

6 Turn the focus ring to adjust the focus.

Looking into the lens when projecting may cause injury to your eyes.

To adjust the volumePress VOLUME +/– keys on the control panel.

To control the computer using the supplied Remote CommanderWhen you connect an IBM PC/AT compatible to the projector, you can control the mouse of the computer using the Remote Commander.The R/L CLICK keys and joystick function as follows.

Make sure that nothing obstructs the infrared beam between the Remote Commander and the remoter control detector on the projector.

To get the clearest pictureYou can adjust picture quality when projecting a signal from the computer.

1 Project a still picture from the computer.

2 Press the APA key. “Complete!” appears on the screen when the picture is adjusted properly.

• Press the APA key when the full image is displayed on the screen. If there are black edges around the image, the APA function will not function properly and the image may extend beyond the screen.

• When you switch the input signal or re-connect a computer, press the APA key again to adjust the picture again.

• You can cancel the adjustment by pressing the APA key again while “ADJUSTING” appears on the screen.

• The picture may not be adjusted properly depending on the kinds of input signals.• Adjust the items in the INPUT SETTING menu when you adjust the picture manually.

Caution

Key and joystick Function

R CLICK (front) Right button

L CLICK (rear) Left button

Joystick Corresponds with the movements of the mouse

Note

Notes

23 GBProjecting

Setting U

p and Projecting

To turn off the power

1 Press the I / 1 key.“POWER OFF? Please press I / 1 key again.” appears to confirm that you want to turn off the power.

A message disappears if you press any key except the I / 1 key, or if you do not press any key for five seconds.

2 Press the I / 1 key again.The ON/STANDBY indicator flashes in green and the fan continues to run for about 90 seconds to reduce the internal heat. Also, the ON/STANDBY indicator flashes quickly for the first 30 seconds. During this time, you will not be able to turn the power back on with the I / 1 key.

3 Unplug the AC power cord from the wall outlet after the fan stops running and the ON/STANDBY indicator lights in red.

When you cannot confirm the on-screen messageWhen you cannot confirm the on-screen message in a certain condition, you can turn off the power by holding the I / 1 key for about one second.

Do not unplug the AC power cord while the fan is still running; otherwise, the fan will stop even though the internal heat is still high, which could result in a breakdown of the projector.

To stow the leg on the bottomIf you are not going to use the projector, close the front cover first and then fold up the leg on the bottom of the projector manually at the end.

On air filterTo maintain optimal performance, clean the air filter every 300 hours.

Note

Note

1-13V

PL-C

S1

GB 24 Using the MENU

Using the MENU

The projector is equipped with an on-screen menu for making various adjustments and settings. You can perform all of the menu operation with the control panel on this unit. Also, you can change the menu language displayed in the on-screen menu.

To change the menu language, see “ Selecting the Menu Language” on page 19.

1 Press the MENU key.The menu appears.The menu presently selected is shown as a yellow button.

2 Use the M or m key to select a menu, then press the , or ENTER key.The selected menu appears.

3 Select an item.Use the M or m key to select the item, then press the , or ENTER key.

4 Make the setting or adjustment on an item.

• When changing the adjustment level:To increase the number, press the M or , key.To decrease the number, press the m or < key.Press the ENTER key to restore the original screen.

• When changing the setting:Press the M or m key to change the setting.Press the ENTER or < key to restore the original screen.

To clear the menuPress the MENU key. The menu disappears automatically if a key is not pressed for one minute.

To reset items that have been adjustedPress the RESET key. “Complete!” appears on the screen and the settings appearing on the screen are reset to their factory preset values. Items that can be reset are: • “CONTRAST,” “BRIGHT,” “COLOR,”

“HUE,” and “SHARP” in the PICTURE CTRL menu

• “DOT PHASE,” “SIZE,” and “SHIFT” in the INPUT SETTING menu.

• “DIGITAL KEYSTONE” in the SET SETTING menu.

About the memory of the settingsThe settings are automatically stored in the projector memory.

If no signal is input If there is no input signal, “NO INPUT–Cannot adjust this item.” appears on the screen.

8 0

5 0

PICTURE CTRL

CONTRAST:

BRIGHT:


COLOR TEMP: HIGH

INPUT-A

SET SETTING

STATUS: ON

INPUT-A: RGB



LANGUAGE: ENGLISH

POWER SAVING: OFF


LAMP TIMER: 00010h

INPUT-A

Menus Setting items

25 GBThe PICTURE CTRL Menu

Overview

The PICTURE CTRL Menu

The PICTURE CTRL (control) menu is used for adjusting the picture. Items that cannot be adjusted depending on the input signal are not displayed in the menu.

For details on the unadjustable items, see page 38.

When the video signal is input

When the RGB signal is input

CONTRASTAdjusts the picture contrast. The higher the setting, the greater the contrast. The lower the setting, the lower the contrast.

BRIGHTAdjusts the picture brightness. The higher the setting, the brighter the picture. The lower the setting, the darker the picture.

COLORAdjusts color intensity. The higher the setting, the greater the intensity. The lower the setting, the lower the intensity.

HUEAdjusts color tones. The higher the setting, the picture becomes greenish. The lower the setting, the picture becomes purplish.

SHARPAdjusts the picture sharpness. The higher the setting, the sharper the picture. The lower the setting, the softer the picture.

D. (Dynamic) PICTUREEmphasizes the black color.

ON: Emphasizes the black color to produce a bolder “dynamic” picture.

OFF: Reproduces the dark portions of the picture accurately, in accordance with the source signal.

GAMMA MODESelects a gamma correction curve.

GRAPHICS: Improves the reproduction of halftones. Photos can be reproduced in natural tones.

TEXT: Contrasts black and white. Suitable for images that contain lots of text.

COLOR TEMPAdjusts the color temperature.

HIGH: Makes the white color bluish.

LOW: Makes the white color reddish.

COLOR SYS (System)Selects the color system of the input signal.• AUTO: NTSC3.58, PAL, SECAM and

NTSC4.43 (switched automatically)• PAL-M/N: PAL-M/PAL-N and NTSC3.58

(switched automatically)Normally, set to AUTO. If the picture is distorted or colorless, select the color system according to the input signal.

Menu Items

PICTURE CTRL

CONTRAST:

BRIGHT:

COLOR:

HUE:

SHARP:

D. PICTURE:

COLOR TEMP:

COLOR SYS:

VIDEO

8 0

5 0

5 0

5 0

5 0

OFF

LOW

AUTO

8 0

5 0

PICTURE CTRL

CONTRAST:

BRIGHT:


COLOR TEMP: HIGH

INPUT-A

1-14V

PL-C

S1

GB 26 The INPUT SETTING Menu

The INPUT SETTING Menu

The INPUT SETTING menu is used to adjust the input signal. Items that cannot be adjusted depending on the input signal are not displayed in the menu.

For details on the unadjustable items, see page 38.

When the video signal is input

When the RGB signal is input

DOT PHASEAdjusts the dot phase of the LCD panel and the signal input from the INPUT A connector. Adjust the picture further for finer picture after the picture is adjusted by pressing the APA key.Adjust the picture to where it looks clearest.

SIZEAdjusts the horizontal size of picture input from the INPUT A connector. The higher the setting, the larger the horizontal size of the picture. The lower the setting, the smaller the horizontal size of the picture. Adjust the setting according to the dots of the input signal.

For details on the suitable value for the preset signals, see page 39.

SHIFTAdjusts the position of the picture input from the INPUT A connector. H adjusts the horizontal position of the picture.V adjusts the vertical position of the picture. As the setting for H increases, the picture moves to the right, and as the setting decreases, the picture moves to the left. As the setting for V increases, the picture moves up, and as the setting decreases, the picture moves down. Use the < or the , key to adjust the horizontal position and the M and m key for the vertical position.

SCAN CONV (Scan converter)Converts the signal to display the picture according to the screen size.

ON: Displays the picture according to the screen size. The picture will lose some clarity.

OFF: Displays the picture while matching one pixel of input picture element to that of the LCD. The picture will be clear but the picture size will be smaller.

When SVGA, XGA or SXGA signal is input, this item will not be displayed.

ASPECTSets the aspect ratio of the picture. When inputting 16:9 (squeezed) signal from equipment such as a DVD player, set to 16:9.

4:3: When the picture with ratio 4:3 is input.

16:9: When the picture with ratio 16:9 (squeezed) is input.

MENU Items

INPUT SETTING VIDEO

4 : 3

N o . 0 1

VIDEO/60

ASPECT:

Memory No.

Signal type

INPUT SETTING

DOT PHASE:

SIZE H

SHIFT H

SCAN CONV: ON

INPUT-A

1 5

8 0 0

H : 2 0 0 V : 3 0

N o . 1 3

640 480

Memory No.

Signal type

Note

27 GBThe SET SETTING Menu

Overview

This projector has 37 types of preset data for input signals for INPUT-A (the preset memory). When a preset signal is input, the projector automatically detects the signal type and recalls the data for the signal from the preset memory to adjust it to an optimum picture. The memory number and signal type of that signal are displayed in the INPUT SETTING menu. You can also adjust the preset data through the INPUT SETTING menu.This projector has 20 types of user memories for INPUT-A into which you can save the setting of the adjusted data for an unpreset input signal.When an unpreset signal is input for the first time, a memory number is displayed as 00. When you adjust the data of the signal in the INPUT SETTING menu, it will be registered to the projector. If more than 20 user memories are registered, the newest memory always overwrites the oldest one.

See the chat on page 39 to find if the signal is registered to the preset memory.

Since the data is recalled from the preset memory about the following signals, you can use these preset data by adjusting SIZE. Make fine adjustment by adjusting SHIFT.

When the aspect ratio of input signal is other than 4:3, a part of the screen is displayed in black.

The SET SETTING Menu

The SET SETTING menu is used for changing the settings of the projector.

STATUS (on-screen display)Sets up the on-screen display.

ON: Shows all of the on-screen displays.

OFF: Turns off the on-screen displays except for the menus, a message when turning off the power, and warning messages.

INPUT-ASelects the RGB or component signal input from the INPUT A connector.

If the setting is not correct, “Please check INPUT-A setting.” appears on the screen and the color of the picture becomes strange or the picture is not displayed.

KEYSTONE MEMORYMemorizes the data adjusted with DIGITAL KEYSTONE.

About the Preset Memory No.

Signal Memory No. SIZE

Super Mac-2 23 1312

SGI-1 23 1320

Macintosh 19" 25 1328

Macintosh 21" 28 1456

Sony News 36 1708

PC-9821 1280 × 1024

36 1600

WS Sunmicro 37 1664

Note

Menu Items

Note

SET SETTING

STATUS: ON

INPUT-A: RGB



LANGUAGE: ENGLISH

POWER SAVING: OFF


LAMP TIMER: 00010h

INPUT-A

1-15V

PL-C

S1

GB 28 The SET SETTING Menu

DIGITAL KEYSTONEAdjusts trapezoidal distortion of the picture that may occur depending on the projection angle.

When the upside of the trapezoid is longer than the downside : Sets to a plus value.

LANGUAGESelects the language used in the menu and on-screen displays. Available languages are: English, French, German, Italian, Spanish, Japanese and Chinese.

POWER SAVINGWhen set to ON, the projector goes into power saving mode if no signal is input for 10 minutes.

SIRCS RECEIVERSelects the remote control detectors (SIRCS receiver) on the front and rear of the projector.

FRONT & REAR: Activates both the front and rear detectors.

FRONT: Activates the front detector only.

REAR: Activates the rear detector only.

LAMP TIMERIndicates the total number of hours for which the lamp currently used has been operated.

29 GBMaintenance

Maintenance

Maintenance

When it is time to replace the lamp, replace the lamp promptly with a new LMP-C120 Projector Lamp.

When replacing the lamp after using the projectorTurn off the projector, then unplug the power cord.Wait for at least an hour for the lamp to cool.

The lamp becomes a high temperature after turning off the projector with the I / 1 key. If you touch the lamp, you may scald your finger. When you replace the lamp, wait for at least an hour for the lamp to cool.

1 Place a protective sheet (cloth) beneath the projector. Turn the projector over so you can see its underside.

Be sure that the projector is stable after turning it over.

2 Open the lamp cover by loosening a screw with the Phillips screwdriver (supplied with the LMP-C120 Projector Lamp).

For safety sake, do not loosen any other screws.

3 Loosen the screw on the lamp unit with the Phillips screwdriver. Pull out the lamp unit by the handle.

4 Insert the new lamp all the way in until it is securely in place. Tighten the screw. Fold up the handle.

• Be careful not to touch the glass surface of the lamp.

• The power will not turn on if the lamp is not secured properly.

5 Close the lamp cover and tighten the screws.

Replacing the Lamp

Caution

Note

Note

Notes

Handle

1-16V

PL-C

S1

GB 30 Maintenance

6 Turn the projector back over.

7 Connect the power cord and turn the projector to standby mode.

8 Press the following keys on the control panel in the following order for less than five seconds each: RESET, <, ,, ENTER.

• Be sure to use the LMP-C120 Projector Lamp for replacement. If you use lamps other than LMP-C120, the projector may cause a malfunction.

• Be sure to turn off the projector and unplug the power cord before replacing the lamp.

• Do not put your hands into the lamp replacement spot, or not fall any liquid or object into it to avoid electrical shock or fire.

The air filter should be cleaned every 300 hours. When it becomes difficult to remove the dust from the filter, replace the filter with a new one. To clean the air filter, follow the steps below:

1 Turn off the power and unplug the power cord.

2 Turn the projector over.

3 Remove the air filter cover.

4 Remove the dust from the filter with a vacuum cleaner.

5 Attach the air filter and replace the cover.

• If the air filter is excessively dirty, wash it with mild detergent solution and dry it in a shaded place. If the dust cannot be removed, replace the air filter with the supplied new one.

• Be sure to attach the air filter cover firmly; the power will not be turned on if it is not closed securely.

• The air filter has a face and a reverse side. Place the air filter so that it fits in a notch on the air filter cover.

Notes

Cleaning the Air Filter

Notes

31 GBTroubleshooting

Maintenance

TroubleshootingIf the projector appears to be operating erratically, try to diagnose and correct the problem using the following instructions. If the problem persists, consult with qualified Sony personnel.

Power

Picture

Symptom Cause and Remedy

The power is not turned on.• The power has been turned off and on with the I / 1 key at a short interval.c Wait for about 90 seconds before turning on the power

(see page 23).• The lamp cover is detached.

c Close the lamp cover securely (see page 29).• The air filter cover is detached.

c Close the air filter cover securely (see page 30).

Both the LAMP/COVER and FAN/TEMP indicators light up.

• The electrical system breaks down.c Consult with qualified Sony personnel.


No picture. • Cable is disconnected or the connections are wrong.c Check that the proper connections have been made

(see page 15).• Input selection is incorrect.

c Select the input source correctly using the INPUT key (see page 21).

• The computer signal is not set to output to an external monitor.c Set the computer signal to output to an external monitor

(see page 15).• The computer signal is set to output to both the LCD of the

computer and external monitor.c Set the computer signal to output only to the external monitor

(see page 15).

The picture is noisy. • Noise may appear on the background depending on the combination of the numbers of dot input from the connector and numbers of pixel on the LCD panel.c Change the desktop pattern on the connected computer.

The picture from INPUT A connector is colored strange.

• Setting for INPUT-A in the SET SETTING menu is incorrect.c Select RGB or COMPONENT for INPUT-A in the SET

SETTING menu according to the input signal (see page 27).

“Please check INPUT-A setting.” appears in spite of inputting the correct signal from INPUT A.

• Setting for INPUT-A in the SET SETTING menu is incorrect.c Select RGB or COMPONENT for INPUT-A in the SET

SETTING menu according to the input signal (see page 27).

On-screen display does not appear.

• STATUS in the SET SETTING menu has been set to OFF.c Set STATUS in the SET SETTING menu to ON (see page 27).

1-17V

PL-C

S1

GB 32 Troubleshooting

Sound

Remote Commander

Others

Color balance is incorrect. • Picture has not been adjusted properly.c Adjust the picture (see page 25).

• Projector is set to wrong color system.c Set COLOR SYS in the PICTURE CTRL menu to match the

color system being input (see page 25).

The picture is too dark. • Contrast or brightness has not been adjusted properly.c Adjust the contrast or brightness in the PICTURE CTRL menu

properly (see page 25).

The picture is not clear. • Picture is out of focus.c Adjust the focus (see page 22).

• Condensation has occurred on the lens.c Leave the projector for about two hours with the power on.

The picture appears too small on the screen.

• SHIFT in the INPUT SETTING menu has not been adjusted properly.c Adjust SHIFT in the INPUT SETTING menu properly (see

page 26).

The picture flickers. • DOT PHASE in the INPUT SETTING menu has not been adjusted properly.c Adjust DOT PHASE in the INPUT SETTING menu properly

(see page 26).


No sound. • Cable is disconnected or the connections are wrong.c Check that the proper connections have been made (see page

15).

When sound is input through AUDIO connector, sound comes through one channel only.

• Monaural sound is being input through the AUDIO connector.c Input stereo sound.


The Remote Commander does not work.

• The Remote Commander batteries are dead.c Replace with new batteries (see page 12).

• The front/rear remote control detector is near the fluorescent lamp.c Change the setting of SIRCS RECEIVER in the SET SETTING

menu (see page 28).

The joystick, R CLICK, or L CLICK key does not function.

• The mouse port on the computer does not recognize the mouse cable.c Restart the computer.


The LAMP/COVER indicator flashes.

• The lamp cover or the air filter cover is detached.c Attach the cover securely (see page 29).


33 GBTroubleshooting

Maintenance

Warning MessagesUse the list below to check the meaning of the messages displayed on the screen.

Caution MessagesUse the list below to check the meaning of the messages displayed on the screen.

The LAMP/COVER indicator lights up.

• The lamp has reached the end of its life.c Replace the lamp (see page 29).

• The lamp becomes a high temperature.c Wait for 90 seconds to cool down the lamp and turn on the

power again (see page 29).

The FAN/TEMP indicator flashes.

• The fan is broken.c Consult with qualified Sony personnel.

The FAN/TEMP indicator lights up.

• The internal temperature is unusually high.c Check to see if nothing is blocking the ventilation holes.

Both the LAMP/COVER and FAN/TEMP indicators light up.

• The electrical system breaks down.c Consult with qualified Sony personnel.

Message Meaning and Remedy

High temp.! Lamp off in 1 min.

• Internal temperature is too high.c Turn off the power.c Check to see if nothing is blocking the ventilation holes.

Frequency is out of range!• This input signal cannot be projected as the frequency is out of the acceptable range of the projector.c Input a signal that is within the range of the frequency.

• The resolution setting of the output signal of a computer is too high.c Set the setting of output to SVGA (see page 15).

Please check INPUT-A setting.

• You have input RGB signal from the computer when INPUT-A in the SET SETTING menu is set to COMPONENT.c Set INPUT-A correctly (see page 27).

Message Meaning and Remedy

NO INPUT • No input signalc Check connections (see page 15).

Not applicable! • You have pressed the wrong key.c Press the appropriate key.


1-18V

PL-C

S1

GB 34 Notes on Installation

Notes on Installation

Do not install the projector in the following situations. These installations may cause malfunction or damage to the projector.

Poorly ventilated

• Allow adequate air circulation to prevent internal heat build-up. Do not place the unit on surfaces (rugs, blankets, etc.) or near materials (curtains, draperies) that may block the ventilation holes. When the internal heat builds up due to the block-up, the temperature sensor will function with the message “High temp.! Lamp off in 1 min.” The power will be turned off automatically after one minute.

• Leave space of more than 30 cm (11 7/8 inches) around the unit.

• Be careful that the ventilation holes may inhale tininess such as a piece of paper.

Highly heated and humid

• Avoid installing the unit in a location where the temperature or humidity is very high, or temperature is very low.

• To avoid moisture condensation, do not install the unit in a location where the temperature may rise rapidly.

Very dustyAvoid installing the unit in a location where there is a lot of dust; otherwise, the air filter will be obstructed. The dust blocking the air through the filter may cause raising the internal heat of the projector. Clean it up periodically.

Do not use the projector under the following conditions.

Toppling the unitAvoid using as the unit topples over on its side. It may cause malfunction.

Tilting the unit

Do not install the unit other than on the floor.Avoid using as the unit tilts upward or downward. These installation may cause malfunction.

Unsuitable Installation

Unsuitable Conditions

�� 35 GBSpecifications

Other

Blocking the ventilation holes

Avoid using something to cover over the ventilation holes (exhaust/intake); otherwise, the internal heat may build up.

Specifications

Optical characteristicsProjection system

3 LCD panels, 1 lens, projection system

LCD panel 0.7-inch TFT LCD panel, 1,440,000 pixels (480,000 pixels × 3)

Lens 1.3 times zoom lens f 28.7 to 37.4 mm/F 1.7 to 2.1

Lamp 120 W UHPProjection picture size

Range: 40 to 150 inches (diagonal measure)

Light output ANSI lumen1) 600 lmThrowing distance (When the SVGA signal is

input)40-inch: 1580 to 2010 mm

(62 1/4 to 78 25/32 inches)60-inch: 2390 to 3060 mm




(191 to 244 1/8 inches)150-inch: 6080 to 7780 mm

(239 1/2 to 306 3/8 inches)

1) ANSI lumen is a measuring method of American National Standard IT 7.228.

Electrical characteristicsColor system NTSC3.58/PAL/SECAM/

NTSC4.43/PAL-M/PAL-N system, switched automatically/manually

Resolution 600 horizontal TV lines (Video input)

800 × 600 dots (RGB input)Acceptable computer signals

fH: 15 to 91 kHz fV: 43 to 85 Hz

Speaker Stereo speakers system, 36 mm (1 7/16 inches) diameter, max. 0.5 W × 2

1-19V

PL-C

S1

GB 36 Specifications

Input/OutputVideo input

VIDEO: phono typeComposite video: 1 Vp-p ±2 dB sync negative (75 ohms terminated)

S VIDEO: Y/C mini DIN 4-pin type (male)Y (luminance): 1 Vp-p ±2 dB sync negative (75 ohms terminated)C (chrominance): burst 0.286 Vp-p ±2 dB (NTSC) (75 ohms terminated), burst 0.3 Vp-p ±2 dB (PAL) (75 ohms terminated)

INPUT A: HD D-sub15-pin (female)Analog RGB/component:

R/R-Y: 0.7 Vp-p ±2 dB(75 ohms terminated)G: 0.7 Vp-p ±2 dB(75 ohms terminated)G with sync/Y: 1 Vp-p ±2 dB sync negative (75 ohms terminated)B/B-Y: 0.7 Vp-p ±2 dB(75 ohms terminated)SYNC/HD:Composite sync input: 1-5 Vp-p high impedance, positive/negativeHorizontal sync input: 1-5 Vp-p high impedance, positive/negativeVD:Vertical sync input: 1-5 Vp-p high impedance, positive/negative

MOUSE: 6-pin (female)(For details, see “Input signals

and adjustable/setting items” on page 38.)

AUDIO: Stereo minijack 500 mVrms, impedance more than 47 kilohms

USB hub: Up (B type: female) × 1Down (A type: female) × 1

Safety regulations:UL1950, CSA No. 950, FCC Class

B, IC Class B NEMKO EN60950, CE, C-Tick,

CCIB

GeneralDimensions 277 × 70 × 214 mm (11 × 2 7/8 ×

8 1/2 inches) (w/h/d) (with the front cover closed, without the projection parts)

Mass Approx. 2.9 kg (6 lb 6 oz) (without strap)

Power requirementsAC 100 to 240 V, 1.9–0.8A,

50/60 HzPower consumption

Max. 190 W (Standby mode: 4.2 W)

Heat dissipation648.4 BTU

Operating temperature0°C to 35°C (32°F to 95°F)

Operating humidity35% to 85% (no condensation)

Storage temperature–20°C to 60°C (–4°F to 140°F)

Storage humidity10% to 90%

Supplied accessoriesRemote Commander RM-PJM1

(1)Size AAA (R03) batteries (2)HD D-sub 15 pin (2 m) (1)PS/2 Mouse Cable (2 m) (1)USB cable A type – B type (1) Application software (1)Carrying case (1)AC power cord (1)Air filter (for replacement) (1)Operating Instructions (1)Quick Reference Card (1)

Design and specifications are subject to change without notice.

Optional accessoriesProjector Lamp LMP-C120 (for replacement)Signal Cable SMF-402 (HD D-sub 15-pin

(male) y 3 × phono type (male))

Monitor CableSMF-410 (HD D-sub 15 pin (male) y HD D-sub 15 pin (male))

Signal Adapter ADP-20 (Macintosh y HD D-

sub 15-pin)Screens 50-inch Portable Screen

VPS-50C1) 100-inch Flat Screen

VPS-100FH120-inch Flat Screen

VPS-120FH

37 GBSpecifications

Other

Some of the items may not be available in some areas. For details, please consult your nearest Sony office.

1) VPS-50C may not be available in some areas. For details, please consult your nearest Sony office.

Pin assignment

INPUT A connector (HD D-sub 15-pin, female)

MOUSE connector (6-pin, female)

1 R/R-Y 9 N.C.

2 G/Y 10 GND

3 B/B-Y 11 GND

4 GND 12 N.C.

5 GND 13 HD/C.Sync

6 GND (R) 14 VD

7 GND (G) 15 N.C.

8 GND (B)

1 DATA

2 N.C.

3 GND

4 +5V

5 CLK

6 N.C.

123

456

1-20V

PL-C

S1


Input signals and adjustable/setting items

PICTURE CTRL menu

z : Adjustable/can be set– : Not adjustable/cannot be set

INPUT SETTING menu

z : Adjustable/can be set– : Not adjustable/cannot be set

Item Input signal

Video or S video (Y/C)

Com-ponent

RGB B&W

CONTRAST z z z z

BRIGHT z z z z

COLOR z z – –

HUE z (NTSC 3.58/4.43 only)

– – –

SHARP z z – z

D. PICTURE z z – z

GAMMA MODE

– – z –

COLOR TEMP

z z z z

COLOR SYS z – – z

Item Input signal

Video or S video (Y/C)

Com-ponent

RGB B&W

DOT PHASE

– – z –

SIZE – – z –

SHIFT – – z –

SCAN CONV

– – z –

ASPECT z z – z

39 GBSpecifications

Other

Preset signals

Memory No.

Preset signal fH (kHz) fV (Hz) Sync SIZE

1 Video 60 Hz 15.734 59.940

2 Video 50 Hz 15.625 50.000

3 15k RGB/Component 60 Hz 15.734 59.940 S on G/Y or Composite Sync

4 15k RGB/Component 50 Hz 15.625 50.000 S on G/Y or Composite Sync

6 640 × 350 VGA mode 1 31.469 70.086 H-pos, V-neg 800

7 VGA VESA 85 Hz 37.861 85.080 H-pos, V-neg 832

8 640 × 400 PC-9801 Normal 24.823 56.416 H-neg, V-neg 848

9 VGA mode 2 31.469 70.086 H-neg, V-pos 800

10 VGA VESA 85 Hz 37.861 85.080 H-neg, V-pos 832

11 640 × 480 VGA mode 3 31.469 59.940 H-neg, V-neg 800

12 Macintosh 13" 35.000 66.667 H-neg, V-neg 864

13 VGA VESA 72 Hz 37.861 72.809 H-neg, V-neg 832

14 VGA VESA 75 Hz 37.500 75.000 H-neg V-neg 840

15 VGA VESA 85 Hz 43.269 85.008 H-neg V-neg 832

16 800 × 600 SVGA VESA 56 Hz 35.156 56.250 H-pos, V-pos 1024

17 SVGA VESA 60 Hz 37.879 60.317 H-pos, V-pos 1056




21 832 × 624 Macintosh 16" 49.724 74.550 H-neg, V-neg 1152

22 1024 × 768 XGA VESA 43 Hz 35.522 43.479 H-pos, V-pos 1264

23 XGA VESA 60 Hz 48.363 60.004 H-neg V-neg 1344

24 XGA VESA 70 Hz 56.476 70.069 H-neg V-neg 1328

25 XGA VESA 75 Hz 60.023 75.029 H-pos, V-pos 1312

26 XGA VESA 85 Hz 68.677 84.997 H-pos, V-pos 1376

27 1152 × 864 SXGA VESA 70 Hz 63.995 70.016 H-pos, V-pos 1472

28 SXGA VESA 75 Hz 67.500 75.000 H-pos, V-pos 1600


30 1152 × 900 Sunmicro LO 61.795 65.960 H-neg, V-neg 1504

31 Sunmicro HI 71.713 76.047 H-neg, V-neg 1472



1-21V

PL-C

S1


Warning on power connectionUse a proper power cord for your local power supply.

1) Note: Use an appropriate rating plug which is applied to local regulations.


35 SGI-5 53.316 50.062 S on G 1680




The United States, Canada

Continental Europe

UK, Ireland, Australia, Newzealand

Japan

Plug type VM0233 290B YP-12A — 1) VM1296

Female end VM0089 386A YC-13B VM0310B VM10505

Cord type SJT SJT H05VV-F N13237/CO-228 HVCTF

Rated Voltage & Current 10A/125V 10A/125V 10A/250V 10A/250V 13A/125V

Safety approval UL/CSA UL/CSA VDE VDE DENTORI

Memory No.

Preset signal fH (kHz) fV (Hz) Sync SIZE

41 GBIndex

Other

Index

AAdjusting

memory of the settings 24the picture .............22, 25the picture size/shift ....26

Air filter ..........................30ASPECT .........................26

BBattery

installation ..................12notes ............................13

BRIGHT .........................25

CCarrying handle ................8COLOR ..........................25COLOR SYS (System) ...25COLOR TEMP ...............25Connections

component equipment 17computer .....................15VCR ............................17

CONTRAST ...................25

DD. (Dynamic) PICTURE 25DIGITAL KEYSTONE ..28DOT PHASE ..................26

GGAMMA MODE ...........25

HHUE ................................25

IINPUT A connector .......11

pin assignment ............37INPUT SETTING menu .26INPUT-A ........................27Installation examples ......14

notes ............................34unsuitable conditions ..34

KKEYSTONE MEMORY 27

LLamp replacement ..........29LAMP TIMER ...............28LANGUAGE .................28

selecting the menu language ..............19

Location and function of controls

connector panel ..........11control panel ...............10front/left/bottom side ....8rear/right side ................8Remote Commander ...12

MMenu

clearing the menu display .................24

INPUT SETTING menu ...................26

PICTURE CTRL menu ...................25

SET SETTING menu .27using the menu ...........24

Messagecaution ........................33warning .......................33

Mouse cableconnection ..................17pin assignment ............37

Mouse connector ............11pin assignment ............37

OOptional accessories .......36

PPICTURE CTRL menu ..25Pin assignment ...............37Power

turn on ........................21POWER SAVING ....10, 28Precautions .......................6

RRemote Commander

battery installation ......12location and function of

controls ...............12Remote control detector

front ..............................8rear ...............................9setting .........................28

Resetresetting the item ........24resttable items .............24

SSCAN CONV (Scan

converter) ................26Screen size ...............14, 35SET SETTING menu .....27SHARP ...........................25SHIFT ............................26SIRCS RECEIVER 8, 9, 28SIZE ...............................26Specifications .................35STATUS (on-screen

display) ...................27Supplied accessories ......36

TTroubleshooting .............31

UUSB connector .........11, 16

VVentilation holes

exhaust ..........................8intake ........................8, 9

1-22V

PL-C

S1

4-074-279-01 (1)

Connections / Connexions / Conexiones / Anschlüsse /Collegamenti

A Stereo audio connecting cable / Câble de connexion audio stéréo / Cable de conexión de audio estéreo / Stereo-Audioverbindungskabel / Cavo di collegamento audio stereo

B HD D-sub 15-pin cable / Câble HD D-sub à 15 broches / Cable HD D-sub 15 pines / 15poliges D-Sub-Kabel hoherDichte / Cavo HD D-sub a 15 piedini

C USB cable / Câble USB / Cable USB / USB-Kabel / Cavo USB

D Mouse cable / Câble de souris / Cable de ratón / Mauskabel / Cavo del mouse

E S-video cable / Câble S-vidéo / Cable de vídeo S / S-Videokabel / Cavo S-Video

F Video cable / Câble vidéo / Cable de vídeo / Videokabel / Cavo video

G Connect another USB equipment / Raccordez un autre appareil USB / Conexión de otro equipo USB /Anschließen eines anderen USB-Geräts / Collegare un altro apparecchio USB

Quick Reference Card / Carte de référence rapide /Tarjeta dereferencia rápida / Kurzreferenz / Scheda di riferimento rapido

VPL-CS1

Sony Corporation © 1999 Printed in Japan

Connecting a VCR / Raccordement à un magnétoscope / Conexión con unavídeograbadora / Anschließen an einen Videorecorder / Collegamento a unvideoregistratore

* not supplied / non fourni / no suministrado / nicht mitgeliefert / non in dotazione

Distance (m (feet)) / Distance (m (pieds))/ Distancia (m (pies)) /Abstand (m) / Distanza (m)

1.6–2.0 (5.2–6.6)

2.4–3.1 (7.8–10.0)

3.2–4.1 (10.5–13.5)

4.0–5.2 (13.2–16.9)

4.9–6.2 (15.9–20.3)

6.1–7.8 (20.0–25.5)

Screen size(inchies) / Taille de l’écran (pouces) / Tamaño de lapantalla (pulgadas) / Projektions-schirmgröße (Zoll) / Dimensioneschermo (pollici)

40

60

80

100

120

150

Projection Distances / Distances de projection / Distancias deproyección / Projektionsentfernungen / Distanze di proiezione


AUDIO OUT

USB

MONITOR OUT


A*

C

B

E*F*

Connecting a computer / Raccordement à un ordinateur / Conexión con ordenador /Anschließen an einen Computer / Collegamento a un computer

● When you use a USB mouse and USB equipment / Lorsque vous utilisez une souris USBet un appareil USB / Si utiliza un ratón USB y un equipo USB / Wenn Sie eine USB-Mausund ein USB-Gerät verwenden / Quando si utilizza un mouse USB e un apparecchio USB

● When you use a PS/2 mouse / Lorsque vous utilisez une souris PS/2 / Si utiliza un ratónPS/2 / Wenn Sie eine PS/2-Maus verwenden / Quando si utilizza un mouse PS/2


AUDIO OUT

MONITOR OUT

MOUSE

A*

D

B

G

S VIDEOOUT

VIDEOOUT

AUDIOOUT

1-23V

PL-C

S1

RESET MENU POWER

INPUT

APA

VOLUME


LAMP/COVER

ENTER

I / 1

INPUTFUNCTION

1

2

R.CLICK

1

24

24APA

5

English

1 Open the front cover, plug the AC power cordinto the wall outlet, then connect allequipment.

2 Press the I / u key to turn on the projector.3 Turn on equipment connected to the

projector.4 Press the INPUT key to select “INPUT-A” or

“VIDEO”.5 Turn the zoom ring to adjust the size of the

picture, and then turn the focus ring to adjustthe focus.

To adjust the picture of computerautomaticallyPress the APA (Auto Pixel Alignment) key.

Français

1 Ouvrez le volet frontal, branchez le câbled'alimentation sur une prise murale etraccordez ensuite tous les appareils.

2 Appuyez sur la touche I / u pour mettre leprojecteur sous tension.

3 Mettez sous tension l’appareil raccordé auprojecteur.

4 Appuyez sur la touche INPUT poursélectionner “ENT.A” ou “VIDEO”.

5 Tournez la bague de mise au point pour réglerla mise au point de l'image optimale, etensuite la bague de zoom pour régler la taillede l'image.

Pour régler l’image d’un ordinateurautomatiquementAppuyez sur la touche APA (Auto PixelAlignment).

Basic Operation / Opération de base / Operación básica /

Grundfunktion / Operazione di base

Español

1 Abra la tapa frontal, enchufe el cable dealimentación de CA en la toma mural y, acontinuación, conecte todo el equipo.

2 Pulse la tecla I / u para encender elproyector.

3 Encienda el equipo conectado al proyector.4 Pulse la tecla INPUT para ajustar “ENTRAD

A” o “VIDEO”.5 Gire el anillo de enfoque para ajustar el

enfoque y, a continuación, gire el anillo dezoom para ajustar el tamaño de la imagen.

Para ajustar la imagen del ordenadorautomáticamentePulse la tecla APA (Auto Pixel Alignment).

Deutsch

1 Öffnen Sie die Abdeckung vorn, stecken Siedas Netzkabel in die Steckdose, und schließenSie alle Geräte an.

2 Schalten Sie den Projektor mit der Taste I / uein.

3 Schalten Sie die an den Projektorangeschlossenen Geräte ein.

4 Wählen Sie mit der Taste INPUT dieEingangsquelle „EING.A“ oder „VIDEO“aus.

5 Stellen Sie durch Drehen des Fokussierringsden Fokus und durch Drehen des Zoom-Ringsdie Größe des Bildes ein.

Zum automatischen Einstellen des Bildesdes ComputersDrucken Sie die Taste APA (Auto PixelAlignment).

Italiano

1 Aprire il coperchio anteriore, inserirel'alimentatore CA nella presa a muro, quindicollegare tutti gli apparecchi.

2 Premere il tasto I / u per accendere ilproiettore.

3 Accendere l’apparecchio collegato alproiettore.

4 Premere il tasto INPUT per selezionare“INGRE A“ o “VIDEO”.

5 Per regolare la messa a fuoco, ruotare ilregolatore apposito, quindi ruotare ilregolatore dello zoom per regolare ledimensioni dell'immagine.

Per regolare l’immagine da un computerautomaticamentePremere il tasto APA (Auto Pixel Alignment).

2-1VPL-CS1

Section 2Service Informations

2-1. Circuit Boards Location

BA

C

B

H

GA

GBB

GBA

QA

NF

2-2. Extension Boards and Flexible Cables

X1 (A-1391-009-A) For : QA, B Boards

X2 (A-1391-010-A) For: QA, B Boards

XC (A-1391-008-A) For: C Board

X3 (A-1391-011-A) For: B, C Boards

X4 (A-1391-024-A) For: B, C Boards

50P (1-900-251-17) For: X3, X4

32P (1-900-251-18) For: B Board

24P (1-900-251-19) For: XC

2-2 VPL-CS1

2-3. Cover Removal

2-4. Front Panel Assy and NF Board Removal

2 Top cover

S holderS holder

Two strap housesCN001

CN814 3 Side cover

1Six shafts

4 Lamp power

6 Screw (+BVTP3 x 10)

1 Four screws (+PS2 x 8)

5 Front panel assy

Unhook the two snaps.

3 Front cover

2 Lock switch

7 NF board

CN806

CN071

2P

2-3VPL-CS1

2-5. C Board Removal

2-6. Optics Unit Assy Removal

• Remove the C Board (Refer to 2-5.).

1 Screw (+PS3 x 5)

2 Earth spring(CT)

3 C board

CN403

CN802

CN807

CN813CN812

CN803

CN811

6 Two screws (+P4 x 8)

7 Optics unit assy

4 Lamp

2 Lamp door

1 Screw (M3)

3 Screw (M3)

5 Screw (+P4 x 8)

2-4 VPL-CS1

2-7. GA, GBA and GBB Boards Removal

• Remove the C Board (Refer to 2-5.).• Remove the optics unit assy (Refer to 2-6.).

2-8. B, BA and QA Boards Removal

• Remove the C Board (Refer to 2-5.).• Remove the optics unit assy (Refer to 2-6.).

6 Two screws (+PS3 x 5)

0 GBB board

8 GA board

4 Lamp house

3 Fan

2 Two screws (FAN)

5 Screw (+P4 x 8)

7 Front chassis

1 Screws (+BTP3 x 8)

CN702CN605

CN707

CN671

9 GBA board

7 B board

4 Two screws


6 Plate(QA)

3 QA board


CN402

CN401

CN201

CN102

CN101

1 BA board

2-5VPL-CS1

2-9. Lens Removal

2-10. Prism Block and In-Polarizer Panel Assy Removal

• Remove the C Board (Refer to 2-5.).• Remove the Optics Unit Assy (Refer to 2-6.).

1 Two screws (+P4 x 8)

2 Lens

5 Screw (+B2.5)

7 Screw (+B2.5)

6 In-polarizer panel (G)assy

8 In-polarizer panel (B)assy

4 In-polarizer panel (R)assy

3 Screw (+B2.5)

1 Two screw (+PSW3 x 8)

2 Prism block

Use extreme care not to touch the glass section of prism, LCD, and conductive section of the flexible cable in particular.

Hold with fingers.

3-1VPL-CS1

Section 3Electrical Adjustments

3-1. Preparations

3-1-1. Equipment Required

. OscilloscopeTektronix 2465 or equivalent(bandwidth: 350 MHz or more)

. NTSC, PAL, SECAM component signal generatorTektronix TG2000 + AVG1 (optional module) + AWVG1(optional module) or equivalent

. VG (Programmable video signal generator)VG814 or equivalent

. Digital voltmeterAdvantest TR6845 or equivalent

. Luminance meter

Note: Perform the following adjustments at least 5minutes after turning on the power.

3-1-2. Optical Unit Adjustment

Drive the cooling fan and turn on the lamp.

3-1-2-1. Mirror Adjustment

Set the screen size to 80-inch at the wide-end.1. Set the unit in green-only.2. Adjust the blanking sections at the top, bottom, left,

and right for minimum by moving the adjusting plateof the G-channel mirror (OPT).

3. Tighten the adjusting plate fixing screws.4. Set the unit in cyan.5. Adjust the blanking sections at the top, bottom, left,

and right for minimum by moving the adjusting plateof the B-channel mirror (OPT), and then maximize theintensity of the blue.

6. Tighten the adjusting plate fixing screws.7. Set the unit in all white.8. Adjust the blanking sections at the top, bottom, left,

and right for minimum by moving the adjusting plateof the R-channel’s first mirror (OPT), and thenmaximize the intensity of the red.

9. Tighten the adjusting plate fixing screws.10. Secure the six adjusting plate fixing screws using a

torque screwdriver.Tightening torque: 8 kgf/cm

11. Make sure that the deviation of the lighting range iswithin the specific range.

3-1-2-2.Polarizing Plate Adjustment

1. Attach the extension cable and the extension flexiblecable to the C board, and input the RGB all black(SVGA 0 IRE Flat Field) signal.

2. Move the red, green, and blue polarizing platesgradually to adjust the black level.

3. Secure the fixing screws using the screwdriver.

Note: When tightening the six fixing screws, be sure topush the polarizing plate toward the radiating side.

3-1-3. Factory Mode Setting

1. Make sure that the STATUS in the menu is ON.2. Exit the menu.3. Press the keys in the following ORDER:

“ENTER” → “ENTER” → “LEFT” → “ENTER”4. The message “Do you wish to enter into the

FACTORY MODE?” will be displayed.5. Select YES.

3-2. V-COM Adjustment

1. Input the green-only 1H inverted signal to INPUT-A.2. Set the CONTRAST to 50 and BRIGHT to 50.3. Set the screen to G VCOM adjustment of “Device

Adjust.”Adjust the G VCOM so that the flicker on the screen isminimum.

4. Input the red-only and blue-only 1H inverted signalrespectively and adjust R VCOM and B VCOMrespectively so that the flicker becomes minimum.

5. Save the value adjusted.

3-2VPL-CS1

Memory Name

Menu Title Item Name SET CH MEMORY STATUS W/B MEMOR MEMORY MEMORY VIDEO VIDEO RGB RGB

VIDEO INPUT-A HIGH LOW HIGH LOW

PICTURE CTRL CONTRAST 80 80

BRIGHT 50 50

COLOR 50 50

HUE 50 50

SHARP 50 50

D.PICTURE OFF OFF

COLOR TEMP LOW HIGH

COLOR SYS AUTO -

GAMMA MODE - GRAPHICS

INPUT SETTING ASPECT 4 : 3 (*)

SIZE H *

SHIFT *

SCAN CONV ON (*)

DOT PHASE 15 (*)

SET SETTING STATUS ON

INPUT-A RGB

KEYSTONE MEMORY OFF

DIGITAL KEYSTONE OFF

LANGUAGE ENGLISH

POWER SAVING OFF

SIRCS RECEIVER FRONT&REAR

LAMP TIMER INDICATION ONLY

INFORMATION fH INDICATION ONLY

fV INDICATION ONLY

ROM Ver INDICATION ONLY

OPERATION TIMER INDICATION ONLY

PREVIOUS LAMP TIMER INDICATION ONLY

W/B ADJUST GAIN R 64 64 64 64

GAIN G 64 60 64 60

GAIN B 64 60 64 60

BIAS R 0 0 0 0

BIAS G 0 0 0 0

BIAS B 0 0 0 0

* : DOT PHASE, SIZE H, SHIFT H/V, SCAN CONV, ASPECT, and BLANKING in the “INPUT SETTING” menu have an initial valuerespectively in accordance with the input signal (PRESET MEMORY No.).

Note : There are nonadjustable items in accordance with the input signal.

3-3. Adjustment Item Initialize Data

3-3VPL-CS1

Memory Name

Menu Title Item Name SET CHROMA MEMORY Reso StatusMEMORY NT358,NT443 PAL,PALM/N YUV Memory Memory Remarks

B&W60 SECAM,B&W 50

RGB MTRX/ CONTRAST 49 47 47

BRIGHT 35 35 35 Fixed Value

SUB HUE 7 8 7

SUB BRT 7 7 7 Fixed Value

R-Y/R 12 11 11

R-Y/B 14 12 13

G-Y/R 9 7 5

G-Y/B 6 6 5

VIDEO CON 9 12 7

VIDEO COL 6 9 7

YUV CON 7 7 9

YUV COL 7 7 7

SUB SHP 2 2 1 Fixed Value

SHP FO 3 3 1 Fixed Value

PRE OVER 0 0 2 Fixed Value

NR LVL 2 2 0 Fixed Value

CEC LVL 2 2 2 Fixed Value

DMIC PIC 2 Fixed Value

DCOM/ VENH 0 Fixed Value

CHROMA/ PAL DVD Non Adjustable Fixed Value

Y-OUT LVL 15

C-OUT LVL 35

Y-DL 8 Fixed Value

S B-Y ADJ 0 Fixed Value

S R-Y ADJ 3 Fixed Value

S-INHBT 0 Fixed Value

S-ID 0 Fixed Value

S GP 0 Fixed Value

S V-ID 0 Fixed Value

BELL f0 0 Fixed Value

BELL/HPF 0 Fixed Value

SHP GAIN 12 12 12 Fixed Value

SHIP EQ 0 0 0 Fixed Value

SHIP F0 2 2 2 Fixed Value


** : It differs in accordance with the resolution of the input signal.


3-4VPL-CS1

Memory Name

Menu Title Item Name SET CHROMA MEMORY Reso Status RemarksMEMORY NT358,NT443 PAL,PALM/N YUV Memory Memory

B&W60 SECAM, B&W 50

P. DRV/ VCOM G 143

VCOM R 182

VCOM B 187

SIG CEN 120 Fixed Value

SID LVL 91

PRG LVL 125

INSTA DOWN 0

INSTA DIR-CNT 0

SH/ SH 1 4

SH 2 67

V AMP CONT 105 Fixed Value

SUB CONT R 128 Fixed Value

SUB CONT G 128 Fixed Value

SUG CONT B 128 Fixed Value

BRT 161 Fixed Value

SC/ HALFTONE BRT 1

GAMMA ON 1

FREEZE 0 (Non memory)

VINIT EVEN ** Fixed Value

VINIT ODD ** Fixed Value

EDMOD 2 (**) Fixed Value

SHOGA 0 Fixed Value

UNSYNCHRO IFV 0 (*)

APA/ APA SH LVL Non Adjustable Fixed Value

SHIFT SH LVL Non Adjustable Fixed Value

PLL/ VCO 0 (*) Fixed Value

CP * Fixed Value

OTHER/ TENP LAMP Non Adjustable Fixed Value

TENP PANEL Non Adjustable Fixed Value

ZOOM 0(Non memory)


** : It differs in accordance with the resolution of the input signal.


3-5VPL-CS1

3-4. Service Kowhow

3-4-1. After Replacing the Prism Block

1. Perform Section “3-1-2-2. Polarizing PlateAdjustment.”

2. Perform Section “3-2. V-COM Adjustment.”3. Perform Section “3-5. White Balance Adjustment on

Servicing.”

3-4-2. After Replacing the Board

. Refer to the cross table below.

. There are no need to perform the adjustment when the boardother than the BA board or C board had been replaced.

3-4-2-1.When Replacing the BA Board

When the data before replacement can be read properly1. Make a not of the data before replacement. After

replacement, write the data into the new board withservice mode.

2. If the white balance is extremely deteriorated, performthe white balance adjustment (Refer to Section 3-5.).

When the data before replacement cannot be read1. Perform Section “3-2. V-COM Adjustment.”2. Perform Section “3-5. White Balance Adjustment on

Servicing.”

3-4-2-2. When Replacing the C Board

1. Perform Section “3-2. V-COM Adjustment.”2. Perform Section “3-5. White Balance Adjustment on

Servicing.”

3-4-2-3.When Replacing the Other Board

There are no need to perform the adjustment.

Cross Table of Board Replacement

Board Name

Device Name Item Name BA C

P.DRV VCOM (R) * \

VCOM (G) * \

VCOM (B) * \

CONT * 95, 100 IRE

SUB CONT R * 95,100 IRE

SUB CONT G * 128 Fixed

SUB CONT B * 95,100 IRE

BRT * 2.8 V

W/B ADJUST

INPUT A-HIGH GAIN R * No

GAIN G * No

GAIN B * No

BIAS R * No

BIAS G * No

BIAS B * No

INPUT A-LOW GAIN R * \

GAIN G * \

GAIN B * \

BIAS R * \

BIAS G * \

BIAS B * \

VIDEO-HIGH GAIN R * No

GAIN G * No

GAIN B * No

BIAS R * No

BIAS G * No

BIAS B * No

VIDEO-LOW GAIN R * \

GAIN G * \

GAIN B * \

BIAS R * \

BIAS G * \

BIAS B * \

* : When down the data befor replacement, and thenwrite in the data after the board replacement.

\ : Need adjustmentValue: See description.

3-6VPL-CS1

3-5. White Balance Adjustment onServicing

3-5-1. Signal Level Adjustment

1. Input the 10 STEP signal to INPUT-A.2. Warm up the unit at least 10 minutes. Enter the V-

AMP/BRT adjustment mode from the Service modeas follows :Service Mode → MENU → DEV. ADJ → P. DRV→ VAMP/BRT.

3. Measure TP808, TP811, and TP812 on the C boardby osciloscope. Adujust V AMP/BRT so that theminimum value in all black level is 2.8 V.

4. Input the 95 IRE and 100 IRE STEP signals.5. Set the unit in G-only mode.6. Enter the P.DRV on the MENU screen by the DEV.

ADJ.7. Discriminate the 95 IRE and 100 IRE by the V-

AMP/CONT controls of the P.DRV.8. Set the unit in R-only mode.9. Discriminate the 95 IRE and 100 IRE by the V-

AMP/SUB CONT R controls of the P.DRV.10. Set the unit in B-only mode.11. Discriminate the 95 IRE and 100 IRE by the V-

AMP/SUB CONT B controls of the P.DRV.

3-5-2. White Balance Adjustment

3-5-2-1.HIGH Mode of INPUT-A

Input the 10 STEP signal to INPUT-A, and observe thechromaticity of each luminance.When varying the chromaticity of each luminance,perform the following adjustments.

1. Input the 100 IRE FLAT FIELD signal to INPUT-A.2. Measure the chromaticity (x, y).3. Input the 50 IRE FLAT FIELD signal to INPUT-A.4. Adjust the chromaticity (x, y) to the values measured

in step 2 by the V-AMP/SUB CONT R and B of theP. DRV.

3-5-2-2.LOW Mode of INPUT-A

1. Input the 80 IRE FLAT FIELD signal to INPUT-A.2. Set the GAIN G to 60 with the LOW mode of the W/B.3. Measure the chromaticity (x, y).4. Input the 25 IRE FLAT FIELD signal to INPUT-A.5. Adjust the chromaticity (x, y) to the values measured in

step 3 by the BIAS G and B of the LOW mode of the W/B.6. Repeat above steps 1 to 5 until the chromaticity become

the following values.x ± 0.002, y ± 0.003 (The x and y are the valuesmeasured in step 3.)

3-5-2-3.HIGH Mode of VIDEO

Switch the input to COMPONENT from INPUT-A by theSET SETTING of the Menu screen.Input the 15k COMPONENT 10 STEP signal to INPUT-A,and observe the chromaticity of each luminance.When varying the chromaticity of each luminance, performthe following adjustments.

1. Input the 100 IRE FLAT FIELD signal to INPUT-A.2. Measure the chromaticity (x, y).3. Input the 50 IRE FLAT FIELD signal to INPUT-A.4. Adjust the chromaticity (x, y) to the values measured in

step 2 by the V-AMP/SUB CONT R and B of the P. DRV.

3-5-2-4.LOW Mode of VIDEO

1. Input the 80 IRE 15k COMPONENT FLAT FIELDsignal to INPUT-A.

2. Set the GAIN G to 60 with the LOW mode of the W/B.3. Measure the chromaticity (x, y).4. Input the 25 IRE FLAT FIELD signal to INPUT-A.5. Adjust the chromaticity (x, y) to the values measured in

step 3 by the BIAS G and B of the LOW mode of the W/B.6. Repeat above steps 1 to 5 until the chromaticity become

the following values.x ± 0.002, y ± 0.003 (The x and y are the valuesmeasured in step 3.)

3-7VPL-CS1

3-6. Memory

Memory structure of VPL-CS1 series is based on the 600series, and it is composed of the following seven memoryblocks.1. Set memory2. Status memory3. Channel memory4. Chroma memory5. W/B memory6. Reso memory7. Gamma memory

When the power plug is connected to the power line(Standby status), all data inside the internal ROM arewritten into the NVM (Nonvolatile Memory). When thepower is turned to on, required data for the current picture,such as status memory data, etc., are selected, and they arewritten into the internal RAM. At this time, the gammamemory data is not writing into the internal RAM but allgraphics/text data will be transferred to the register insidethe device instead.

When adjustment is carried out, adjustment data arewritten into the NVM automatically (items on the usermode) or by the trigger of memory operation (items on theservice mode and special service mode).

Adjustable items (W/B and Device Adjust) of the servicemode and special service are memorized into the NVM bythe memory operation. At the same time, the factory preset(adjusted) data are all eliminated from the memory.

Set Memory

Status Memory

No.01

No.02

No.03

INP

UT

-A P

reset

...

...

No.50

Reso No. 0......

Reso No.17

W/B Memory

Com

puterO

thers

HIGH

LOW

HIGH

LOW

Set Memory

Status Memory

No.01

No.02

No.03

INP

UT

-A P

resetIN

PU

T-A

U

ser

...

...

No.50

No.71...

No.90

Set Memory

Status Memory

Channel Memory

Video

Input-A

Chroma Memory

NT358/443/BW60

PAL/PAL-M/N/ SECAM/BW5015k Component

W/B Memory

Com

puterO

thers

HIGH

LOW

HIGH

LOW

Reso Memory

Reso No. 0......

Reso No.17

Reso Memory

W/B Memory

HIGH

LOW

Channel Memory

Video

Input-A

Gamma Memory

Graphics

Text

Gamma Memory Output to device directly

Graphics

Text

Chroma Memory

NT358/443/BW60

PAL/PAL-M/N/ SECAM/BW50

15k Component

Channel Memory

Chroma Memory

Reso Memory

CPU ROM External NVM CPU RAM

Active memory copy

MemoryInitialize

4-1VPL-CS1

Section 4Semiconductors

BA12FP-E2

VCCN.C

OUT

GND

CXA1846BN

FA5331M-TE1

ISPLSI1016E-80LT44

IP00C711

1 64

192 129

65

128

256

193

(TOP VIEW)

M52749FP-TP

42

1

22

21

CXA2112R-T6

CXA1839Q-T6CXD2064Q-T6

PQ05SZ1U

BA033FP-E2LT1376IS#TRMC100ELT20DR2NJM2073M(TE2)SN74CBTD3306PWRTC7W08FUTL431BCDR2

RS-140-T

TA78M09F(TE16L)

12 3

TC7S04FUTC7SH08FU-TE85R

TOP222Y-BBTOP223Y-BB

74VHC14MTCXTC74LCX04FT(EL)TC74LCX74FTTC74VHCT04AFTTC74VHCT04MTCXTC74VHC125MTCX

74VHC240MTCXMB88346BPFV-EF

74VHC221AMTCXCXA1875AM-T4MAX4066CEE-TE2

HN1B01FU-TE85R

2SA1162-YG-TE85L2SA1213Y-TE12L2SA14622SC2712-YG-TE85LDTA144EKA-T146DTC144EKA-T146

2SC2873Y-TE12L

2SD2114S-TP-V

DG

S

Letter Side

2SK3013F-02

DAN202K-T-146

D1FL20U-TAD1FS4A-TA

D10SC9M

FCQ20A06

RD24M-T1B2RD8.2M-T1B1

RD8.2ES-T1B2

4-2 VPL-CS1

SEC1801CSEC2422CSEC2422C

TF861S

1SS355TE-17D2FS6-TADTZ-TT11-5.1RB501V-40TE-17RD5.6SB-T1RD9.1SB2-T1UDZ-TE-17-3.9B

VPL-CS1 5-1

Section 5Exploded Views

5-1. Cover

Cover

REF NO. PART NO. DESCRIPTION REMARK REF NO. PART NO. DESCRIPTION REMARK

1 * 4-074-275-01 COVER, FRONT2 * X-4037-487-1 HANDLE ASSY3 * 4-074-231-01 EMBLEM (CS1)4 4-074-251-01 SWITCH, LOCK5 * 4-074-434-01 SPRING, EXTENSION

6 * 4-074-255-01 HOLDER (L), FRONT COVER7 * 4-074-254-01 HOLDER (R), FRONT COVER8 * 4-074-245-01 HINGE (F)9 * 4-074-627-01 COVER, BACK

10 * X-4037-461-1 PANEL ASSY, FRONT including 11

11 3-704-176-51 EMBLEM (NO.6), SONY12 * A-1390-984-A NF MOUNT13 * 4-074-442-01 CATCHER (FC)14 * 4-074-253-01 HOLDER (L), B15 * 4-074-252-01 HOLDER (R), B

16 1-468-457-11 POWER, LAMP17 4-374-303-01 RIVET, NYLON18 1-500-082-11 CLAMP, SLEEVE FERRITE19 * 4-074-272-01 COVER, TOP20 * 4-074-261-01 HOUSE, STRAP

21 * 4-074-744-01 HOLDER, S22 * 4-074-248-01 KEY TOP23 * 4-074-244-01 GUIDE (LED), LIGHT24 * A-1375-195-A H COMPL25 1-529-544-11 SPEAKER (3.6CM)

26 * 4-074-273-01 COVER, SIDE27 4-074-264-01 SHAFT

: 7-685-647-79 +BWTP 3x10 : 7-682-547-14 +BTP 3x10 : 7-682-645-09 +PS 3x5 : 7-628-253-30 +PS 2x8 12

10

11

13

17

14

16

21

20

22

18

2415

20

21

193

23

25

27

9

46

8

8

7

5

2

1

3

26

• Items marked “ * ” are not stocked since they are seldom requiredfor routine service. Some delay should be anticipated when order-ing these items.

• Items with no part number and no description are not stocked be-cause they are seldom required for routine service.

• The construction parts of an assembled part are indicated with acollation number in the remarks column.

The components identified marked ! arecritical for safety.Replace only with the part number specified.

Les composants identifiés par la marque !sont critiques pour la sécurité.Ne les remplacer que par une pièce portantle numéro spécifié.

NOTE :

VPL-CS15-2

5-2. Chassis

Chassis

REF NO. PART NO. DESCRIPTION REMARKREF NO. PART NO. DESCRIPTION REMARK REF NO. PART NO. DESCRIPTION REMARK

51 * 4-074-983-01 SPRING (CT), EARTH52 * A-1335-123-A C COMPL53 4-066-309-01 SCREW, MACHINE, (+) P M4X854 A-1501-636-A OPTICS BLOCK ASSY including 152 to 19255 * X-4037-521-1 NOZZLE, ASSY

56 * A-1136-048-A BA COMPL57 * A-1275-186-A QA COMPL58 * A-1136-049-A B COMPL59 * 4-074-914-01 COVER, SWITCH60 * 4-074-664-01 LEVER, SWITCH

61 * 4-074-982-01 SPRING (VIDEO), EARTH62 * 4-074-246-01 SLEEVE, VIDEO63 * 4-074-263-01 FILTER, REAR64 * 4-074-260-01 PLATE (QA)65 1-763-474-11 FAN

66 * 4-074-227-01 DUCT (T)67 * 4-074-226-01 DUCT (B)68 * 4-074-276-01 HOUSE, LAMP69 * 4-074-727-01 LOUVER (A)70 * 4-074-728-01 LOUVER (B)

71 1-763-172-11 FAN, DC72 * 4-074-239-01 SCREW, FAN73 1-900-222-47 CONNECTOR ASSY 2P74 4-066-202-01 SCREW, M375 * X-4037-460-1 DOOR ASSY, LAMP including 76

76 4-066-202-01 SCREW, M3

: 7-682-646-09 +PS 3x5 : 7-682-253-30 +PS 2x8 : 7-685-647-79 +BVTP 3x10 : 7-685-903-21 +BTPWH 3x8 : 7-685-645-79 +BVTP 3x6 : 7-682-247-09 +K 3x6

52 51 56

58

57 60

63

61 62

64

67

66

69

71

72

68

70

73

74

75

76

5965

54

53

55

VPL-CS1 5-3

5-3. Base

Base


101 * A-1316-492-A GA COMPL102 1-500-082-11 CLAMP, SLEEVE FERRITE103 * 4-074-660-01 PLATE (AC)104 ! 1-251-382-12 INLET, AC 3P(WITH NOISE FILTE)105 4-066-309-01 SCREW, MACHINE, (+) P M4X8

106 * 4-074-663-01 SPRING (BL), EARTH107 * 4-074-256-01 CASE (U), L108 * 4-074-258-01 LOCK (REAR FOOT)109 * 4-074-435-01 SPRING, COMPRESSION110 * 4-074-247-01 ROD

111 * 4-074-257-01 CASE (B), L112 * 4-074-724-01 CASE (RF)113 * 4-075-060-01 SPRING, COMPRESSION114 * 4-074-725-01 SLIDER (RF)115 * 4-074-274-01 BASE

116 * 4-074-661-01 HOLDER, FAN117 * 4-074-662-01 PLATE, FAN HOLDER118 3-531-576-11 RIVET119 * 4-074-441-01 COVER, FILTER120 3-661-278-01 PIN, PARALLEL

121 * 4-074-241-01 HOLDER (L), REAR FOOT122 * 4-074-242-01 HOLDER (R), REAR FOOT123 3-703-358-03 PIN, PARALLEL (DIA. 2X8)124 * 4-074-984-01 SPRING, TOSION125 * 4-074-729-01 PLATE (RF)

126 * 4-074-726-01 LEVER (RF)127 * 4-074-267-01 FOOT, REAR128 4-074-250-01 RUBBER, FOOT (R)

: 7-685-547-14 +BTP 3x10 : 7-682-247-09 +K 3x6 : 7-682-646-09 +PS 3x5 : 7-682-245-04 +K 3x4

102

101

106

110

107

113

120

121

120 122123

125

128127

115

104

103

105

116

117

118

119

126

124

112

114

111

108

109

VPL-CS15-4


5-4. Optics (1/2)

Optics (1/2)

151 A-1501-636-A OPTICS BLOCK ASSY including 152 to 192152 A-1484-705-A PRISM BLOCK ASSY including 202 to 209153 4-074-425-01 TAPE (A), SEAL154 4-074-474-01 BSW M3X8155 4-066-174-01 STOPPER (OPT), ROTATION

156 * 4-074-405-01 FASTENER (RB)157 * 4-074-454-01 ADJUSTER, R-MIRROR158 * 4-074-476-01 FASTNER (G)159 * 4-074-466-01 ADJUSTER, G-MIRROR160 * 4-074-455-01 ADJUSTER, B-MIRROR

161 3-696-947-11 SCREW(+B2.5)162 A-1501-633-A PANEL (R) ASSY, IN-POLARIZER163 A-1501-634-A PANEL (G) ASSY, IN-POLARIZER164 A-1501-635-A PANEL (B) ASSY, IN-POLARIZER165 * 4-074-429-01 STOPPER, RELAY LENS-2

166 * 4-074-433-01 STOPPER, RELAY LENS-1167 * 4-074-432-01 STOPPER (GB), CH CONDENSER168 * 4-074-475-01 STOPPER, FLY EYE169 * 4-074-430-01 STOPPER, MAIN CONDENSER”170 * 4-074-428-01 STOPPER, P/S

171 * 4-074-412-01 MIRROR, R-CHANNEL-2(OPT)

172 * 4-074-410-01 LENS (OPT), RELAY-3173 * 4-074-409-01 LENS (OPT), RELAY-2174 * 4-074-413-01 MIRROR, R-CHANNEL -1(OPT)175 * 4-074-408-01 LENS (OPT), RELAY-1

176 * 4-074-407-01 DICHROICMIRROR, G-REFRECT(OPT)177 * 4-074-427-01 CUSHION (B-DM)178 * 4-074-406-01 DICHROICMIRROR, B-REFRECT(OPT)179 * 4-074-411-01 FILTER (OPT), UV CUT180 * 4-074-414-01 LENS, MAIN CONDENSER (OPT)

181 A-1484-706-A P/S BLOCK ASSY including 211 to 218182 * 4-074-426-01 CUSHION (FLY EYE)183 * 4-074-449-01 FLY EYE LENS-1184 * 4-074-416-01 LENS, CONDENSER-R-CH(OPT)185 * 4-074-418-01 LENS, CONDENSER-G-CH(OPT)

186 * 4-074-417-01 LENS, CONDENSER-B-CH(OPT)187 4-066-309-01 SCREW, MACHINE, (+) P M4X8188 4-066-172-01 FASTENER (OPT), MIRROR189 * 4-074-415-01 MIRROR, B-CHANNEL (OPT)190 * 4-074-429-11 STOPPER, RELAY LENS-2

191 * 4-074-426-11 CUSHION (FLY EYE)192 * 4-075-039-01 SPACER (C) (OPT)

: 7-682-547-04 +B 3x6

187

186

184

191

171

172

161151

164

165

166

167

174

190

169

168

192

170

175

185 176

179

191

178177

180

181

182

183

189

173

188

162

161 161

163153

156

154

155

157

153154

155

159

158

154153

155

160

156

152

B

A

AB

BC

C

D

D

VPL-CS1 5-5

5-5. Optics (2/2)

Optics (2/2)


201 A-1484-705-A PRISM BLOCK ASSY including 202 to 209202 4-074-473-01 +K M1.7X6203 A-1501-637-A PANEL (R) ASSY, OUT-POLARIZER204 A-1501-638-A PANEL (G) ASSY, OUT-POLARIZER205 A-1501-639-A PANEL (B) ASSY, OUT-POLARIZER

206 A-1484-705-A PRISM ASSY, 4P207 A-1501-632-A LENS, PROJECTION208 4-066-309-01 SCREW, MACHINE, (+) P M4X8209 * 4-074-701-01 BRACKET, WINDOW210 4-066-309-01 SCREW, MACHINE, (+) P M4X8

211 A-1484-706-A P/S BLOCK ASSY including 211 to 218212 * 4-074-456-01 SPRING, P/S213 * 4-074-446-01 CONVERTER, P/S (OPT)214 * 4-074-477-01 SLIT, P/S215 * 4-074-471-01 HOLDER, P/S

216 * 4-074-426-11 CUSHION (FLY EYE)217 * 4-074-448-01 FLY EYE LENS-2218 * 4-074-457-01 SPRING, FLY EYE

: 7-685-103-19 +P 2x5 : 7-682-948-01 +PSW 3x8 : 7-627-554-38 +P 2x1.8

203202

201

206

207

209

205

204

202

211

212213

214

215

216 217

218

202210

208

6-1VPL-CS1

Ref.No. Part No. Description RemarkRef.No. Part No. Description Remark

Section 6Electrical Parts List

* A-1136-048-A BA COMPL**********************

<CAPACITOR>

C201 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC202 1-126-204-11 ELECT CHIP 47µF 20% 16VC221 1-117-681-11 ELECT CHIP 100µF 20% 16VC222 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC224 1-113-985-11 TANTAL. CHIP 10µF 20% 20V

C225 1-104-852-11 TANTAL. CHIP 22µF 20% 10VC226 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC227 1-117-681-11 ELECT CHIP 100µF 20% 16VC228 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC230 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

C232 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC233 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC234 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC235 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC236 1-117-681-11 ELECT CHIP 100µF 20% 16V

C237 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC238 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC239 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC240 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC241 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V


C247 1-131-998-21 TANTALUM 82µF 20% 6.3VC274 1-104-823-11 TANTAL. CHIP 47µF 20% 16VC275 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC276 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC277 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50V

C278 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC279 1-107-682-11 CERAMIC CHIP 1µF 10% 16VC280 1-124-779-00 ELECT CHIP 10µF 20% 16VC281 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC282 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50V



C296 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC297 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC300 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC301 1-126-204-11 ELECT CHIP 47µF 20% 16VC302 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

C303 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50VC304 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC312 1-124-779-00 ELECT CHIP 10µF 20% 16VC313 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC314 1-107-823-11 CERAMIC CHIP 0.47µF 10% 16V

C315 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC317 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC318 1-126-603-11 ELECT CHIP 4.7µF 20% 35VC319 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC320 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

C321 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC322 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC323 1-125-838-91 CERAMIC CHIP 2.2µF 10% 6.3VC324 1-163-037-11 CERAMIC CHIP 0.022µF 10% 50VC325 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50V

C326 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC327 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC328 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC330 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC331 1-126-204-11 ELECT CHIP 47µF 20% 16V

C332 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC333 1-126-204-11 ELECT CHIP 47µF 20% 16VC334 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC337 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC338 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

<CONNECTOR>

CN201 * 1-785-305-21 CONNECTOR, BOARD TO BOARD 70P

<FERRITEBEAD>

FB201 1-414-235-22 INDUCTOR CHIP 0µHFB202 1-500-245-11 INDUCTOR CHIP 0µHFB271 1-414-235-22 INDUCTOR CHIP 0µH

BA



NOTE :• Items marked * are not stocked since they are seldom required

for routine service. Some delay should be anticipated when order-ing these items.

• Due to standardization, replacements in the parts list may be dif-ferent from the parts specified in the diagrams or the componentsused on the set.

RESISTORS• All resistors are in ohms.• F: nonflammable• METAL: Metal-film resistor• METAL OXIDE: Metal oxide-film resistor

6-2 VPL-CS1


<FILTER>

FL221 1-239-397-11 FILTER, LOW PASSFL222 1-239-397-11 FILTER, LOW PASSFL223 1-239-397-11 FILTER, LOW PASSFL301 1-239-899-21 FILTER, CHIP EMIFL302 1-239-899-21 FILTER, CHIP EMI

FL303 1-239-899-21 FILTER, CHIP EMI

<IC>

IC201 8-752-072-94 IC CXA1875AM-T4IC202 8-759-492-55 IC M24C64-WMN6TIC221 8-752-390-37 IC CXD2064Q-T6IC271 8-752-070-54 IC CXA1839Q-T6IC301 8-752-094-47 IC CXA2123AQ-T6

IC302 8-759-494-88 IC TC75S56F(TE85R)

<COIL>

L221 1-414-753-91 INDUCTOR 4.7µHL222 1-414-235-22 INDUCTOR CHIP 0µHL223 1-414-753-91 INDUCTOR 4.7µHL224 1-414-753-91 INDUCTOR 4.7µHL225 1-414-753-91 INDUCTOR 4.7µH

L226 1-414-753-91 INDUCTOR 4.7µHL271 1-414-235-22 INDUCTOR CHIP 0µH

<TRANSISTOR>

Q221 8-729-230-49 TRANSISTOR 2SC2712-YGQ222 8-729-216-22 TRANSISTOR 2SA1162-GQ226 8-729-216-22 TRANSISTOR 2SA1162-GQ227 8-729-230-49 TRANSISTOR 2SC2712-YGQ228 8-729-216-22 TRANSISTOR 2SA1162-G

Q229 8-729-230-49 TRANSISTOR 2SC2712-YGQ271 8-729-013-28 TRANSISTOR HN1B01FU-TE85RQ272 8-729-013-28 TRANSISTOR HN1B01FU-TE85RQ273 8-729-013-28 TRANSISTOR HN1B01FU-TE85RQ302 8-729-230-49 TRANSISTOR 2SC2712-YG

Q303 8-729-230-49 TRANSISTOR 2SC2712-YG

<RESISTOR>

R201 1-216-065-91 RES,CHIP 4.7K 5% 1/10WR202 1-216-073-00 RES,CHIP 10K 5% 1/10WR203 1-216-025-91 RES,CHIP 100 5% 1/10WR204 1-216-025-91 RES,CHIP 100 5% 1/10WR205 1-216-025-91 RES,CHIP 100 5% 1/10W

R206 1-216-025-91 RES,CHIP 100 5% 1/10WR207 1-216-025-91 RES,CHIP 100 5% 1/10WR208 1-216-025-91 RES,CHIP 100 5% 1/10WR209 1-216-025-91 RES,CHIP 100 5% 1/10WR210 1-216-025-91 RES,CHIP 100 5% 1/10W

R211 1-216-073-00 RES,CHIP 10K 5% 1/10WR212 1-216-073-00 RES,CHIP 10K 5% 1/10WR213 1-216-025-91 RES,CHIP 100 5% 1/10WR214 1-216-025-91 RES,CHIP 100 5% 1/10WR215 1-216-025-91 RES,CHIP 100 5% 1/10W

R216 1-216-073-00 RES,CHIP 10K 5% 1/10WR217 1-216-073-00 RES,CHIP 10K 5% 1/10WR218 1-216-073-00 RES,CHIP 10K 5% 1/10WR222 1-216-081-00 RES,CHIP 22K 5% 1/10WR223 1-216-065-91 RES,CHIP 4.7K 5% 1/10W

R225 1-216-043-91 RES,CHIP 560 5% 1/10WR227 1-216-049-91 RES,CHIP 1K 5% 1/10W

R228 1-216-049-91 RES,CHIP 1K 5% 1/10WR230 1-216-085-00 RES,CHIP 33K 5% 1/10WR231 1-216-051-00 RES,CHIP 1.2K 5% 1/10W

R234 1-216-067-00 RES,CHIP 5.6K 5% 1/10WR235 1-216-043-91 RES,CHIP 560 5% 1/10WR236 1-216-295-91 SHORT 0R237 1-216-049-91 RES,CHIP 1K 5% 1/10WR239 1-216-049-91 RES,CHIP 1K 5% 1/10W

R242 1-216-067-00 RES,CHIP 5.6K 5% 1/10WR243 1-216-043-91 RES,CHIP 560 5% 1/10WR244 1-216-025-91 RES,CHIP 100 5% 1/10WR245 1-216-049-91 RES,CHIP 1K 5% 1/10WR247 1-216-043-91 RES,CHIP 560 5% 1/10W

R249 1-216-631-11 METAL CHIP 150 0.50% 1/10WR250 1-216-631-11 METAL CHIP 150 0.50% 1/10WR251 1-216-053-00 RES,CHIP 1.5K 5% 1/10WR252 1-216-061-00 RES,CHIP 3.3K 5% 1/10WR253 1-216-057-00 RES,CHIP 2.2K 5% 1/10W

R254 1-216-091-00 RES,CHIP 56K 5% 1/10WR255 1-216-043-91 RES,CHIP 560 5% 1/10WR256 1-216-295-91 SHORT 0R258 1-216-295-91 SHORT 0R259 1-216-295-91 SHORT 0

R271 1-216-025-91 RES,CHIP 100 5% 1/10WR272 1-216-635-11 METAL CHIP 220 0.50% 1/10WR273 1-216-655-11 METAL CHIP 1.5K 0.50% 1/10WR274 1-216-083-00 RES,CHIP 27K 5% 1/10WR275 1-216-295-91 SHORT 0

R276 1-216-081-00 RES,CHIP 22K 5% 1/10WR277 1-216-085-00 RES,CHIP 33K 5% 1/10WR278 1-216-647-11 METAL CHIP 680 0.50% 1/10WR279 1-216-655-11 METAL CHIP 1.5K 0.50% 1/10WR280 1-216-081-00 RES,CHIP 22K 5% 1/10W

R281 1-216-295-91 SHORT 0R282 1-216-085-00 RES,CHIP 33K 5% 1/10WR283 1-216-073-00 RES,CHIP 10K 5% 1/10WR284 1-216-025-91 RES,CHIP 100 5% 1/10WR285 1-216-025-91 RES,CHIP 100 5% 1/10W

R286 1-216-651-11 METAL CHIP 1K 0.50% 1/10WR287 1-216-651-11 METAL CHIP 1K 0.50% 1/10WR288 1-216-025-91 RES,CHIP 100 5% 1/10WR289 1-216-025-91 RES,CHIP 100 5% 1/10WR290 1-216-025-91 RES,CHIP 100 5% 1/10W

R291 1-216-081-00 RES,CHIP 22K 5% 1/10WR292 1-216-085-00 RES,CHIP 33K 5% 1/10WR293 1-216-295-91 SHORT 0R294 1-216-049-91 RES,CHIP 1K 5% 1/10WR296 1-216-033-00 RES,CHIP 220 5% 1/10W

R298 1-216-025-91 RES,CHIP 100 5% 1/10WR299 1-216-025-91 RES,CHIP 100 5% 1/10WR300 1-216-025-91 RES,CHIP 100 5% 1/10WR302 1-216-295-91 SHORT 0R303 1-216-295-91 SHORT 0

R304 1-208-796-11 METAL CHIP 3.9K 0.50% 1/10WR305 1-216-025-91 RES,CHIP 100 5% 1/10WR306 1-216-037-00 RES,CHIP 330 5% 1/10WR309 1-216-663-11 METAL CHIP 3.3K 0.50% 1/10WR310 1-216-685-11 METAL CHIP 27K 0.50% 1/10W

R311 1-216-667-11 METAL CHIP 4.7K 0.50% 1/10WR312 1-216-025-91 RES,CHIP 100 5% 1/10WR313 1-216-025-91 RES,CHIP 100 5% 1/10WR314 1-216-049-91 RES,CHIP 1K 5% 1/10WR315 1-216-049-91 RES,CHIP 1K 5% 1/10W

R316 1-216-061-00 RES,CHIP 3.3K 5% 1/10WR317 1-216-069-00 RES,CHIP 6.8K 5% 1/10WR318 1-216-017-91 RES,CHIP 47 5% 1/10W

BA

6-3VPL-CS1


R319 1-216-017-91 RES,CHIP 47 5% 1/10WR320 1-216-017-91 RES,CHIP 47 5% 1/10W

R321 1-216-025-91 RES,CHIP 100 5% 1/10WR322 1-216-295-91 SHORT 0R324 1-216-017-91 RES,CHIP 47 5% 1/10W

<CRYSTAL>

X301 1-781-730-21 VIBRATOR, CRYSTAL (16.2MHz)

*************************************************************

* A-1136-049-A B COMPL**********************

<CAPACITOR>

C401 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC402 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC403 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC404 1-162-970-11 CERAMIC CHIP 0.01µF 10% 25VC405 1-126-204-11 ELECT CHIP 47µF 20% 16V

C406 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC407 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC408 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC409 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC410 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V

C411 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC412 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC413 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC414 1-162-970-11 CERAMIC CHIP 0.01µF 10% 25VC415 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V

C416 1-162-967-11 CERAMIC CHIP 0.0033µF 10% 50VC417 1-126-204-11 ELECT CHIP 47µF 20% 16VC420 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC421 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC422 1-162-970-11 CERAMIC CHIP 0.01µF 10% 25V

C424 1-126-204-11 ELECT CHIP 47µF 20% 16VC426 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC427 1-115-566-11 CERAMIC CHIP 4.7µF 10% 10VC428 1-164-816-11 CERAMIC CHIP 220PF 2% 50VC429 1-115-566-11 CERAMIC CHIP 4.7µF 10% 10V

C430 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC431 1-162-970-11 CERAMIC CHIP 0.01µF 10% 25VC432 1-124-778-00 ELECT CHIP 22µF 20% 6.3VC433 1-115-566-11 CERAMIC CHIP 4.7µF 10% 10VC434 1-115-566-11 CERAMIC CHIP 4.7µF 10% 10V

C435 1-115-566-11 CERAMIC CHIP 4.7µF 10% 10VC436 1-110-563-11 CERAMIC CHIP 0.068µF 10% 16VC437 1-124-779-00 ELECT CHIP 10µF 20% 16VC438 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC439 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V

C440 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC442 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC443 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC444 1-124-778-00 ELECT CHIP 22µF 20% 6.3VC445 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V


C451 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC452 1-110-563-11 CERAMIC CHIP 0.068µF 10% 16VC453 1-162-970-11 CERAMIC CHIP 0.01µF 10% 25V

C454 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC455 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V







C487 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC489 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC490 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC491 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC495 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V

C496 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC497 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC498 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC499 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC500 1-162-927-11 CERAMIC CHIP 100PF 5% 50V

C501 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC502 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC503 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC504 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC505 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V




C521 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC522 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC523 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC524 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V

BA B

6-4 VPL-CS1


C525 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V



C536 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC537 1-162-970-11 CERAMIC CHIP 0.01µF 10% 25VC538 1-115-156-11 CERAMIC CHIP 1µF 10VC539 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC540 1-115-156-11 CERAMIC CHIP 1µF 10V

C541 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC542 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC543 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC544 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC545 1-164-315-11 CERAMIC CHIP 470PF 5% 50V

C546 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC547 1-162-915-11 CERAMIC CHIP 10PF 0.5PF 50VC548 1-124-778-00 ELECT CHIP 22µF 20% 6.3VC549 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC550 1-124-778-00 ELECT CHIP 22µF 20% 6.3V

C551 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC553 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC554 1-162-927-11 CERAMIC CHIP 100PF 5% 50VC555 1-124-778-00 ELECT CHIP 22µF 20% 6.3VC556 1-162-970-11 CERAMIC CHIP 0.01µF 10% 25V

C557 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC558 1-124-778-00 ELECT CHIP 22µF 20% 6.3VC559 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC560 1-162-966-11 CERAMIC CHIP 0.0022µF 10% 50VC561 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V



C573 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC574 1-124-778-00 ELECT CHIP 22µF 20% 6.3VC575 1-162-970-11 CERAMIC CHIP 0.01µF 10% 25VC576 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC577 1-124-778-00 ELECT CHIP 22µF 20% 6.3V

C578 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16VC579 1-162-970-11 CERAMIC CHIP 0.01µF 10% 25VC581 1-107-826-91 CERAMIC CHIP 0.1µF 10% 16V

<CONNECTOR>

CN401 * 1-785-305-21 CONNECTOR, BOARD TO BOARD 70PCN402 * 1-793-797-21 CONNECTOR, BOARD TO BOARDCN403 * 1-793-797-21 CONNECTOR, BOARD TO BOARDCN404 1-569-577-41 CONNECTOR, D-SUB 15PCN405 1-774-932-21 CONNECTOR, FF C/FPC (ZIF) 32P

CN406 * 1-691-551-11 PIN, CONNECTOR (SMD) 8P

<DIODE>

D401 8-719-800-76 DIODE 1SS226D402 8-719-800-76 DIODE 1SS226D403 8-719-800-76 DIODE 1SS226D404 8-719-800-76 DIODE 1SS226D406 8-719-800-76 DIODE 1SS226

D408 8-719-914-43 DIODE DAN202KD409 8-719-914-43 DIODE DAN202KD410 8-719-158-15 DIODE RD5.6SBD411 8-719-158-15 DIODE RD5.6SBD412 8-719-158-15 DIODE RD5.6SB

D413 8-719-988-61 DIODE 1SS355TE-17D414 8-719-988-61 DIODE 1SS355TE-17D415 8-719-158-15 DIODE RD5.6SB

<FERRITE BEAD>

FB401 1-414-234-22 INDUCTOR CHIP 0µHFB402 1-414-234-22 INDUCTOR CHIP 0µHFB403 1-414-234-22 INDUCTOR CHIP 0µHFB404 1-414-234-22 INDUCTOR CHIP 0µHFB405 1-414-234-22 INDUCTOR CHIP 0µH


FB412 1-414-234-22 INDUCTOR CHIP 0µHFB413 1-414-234-22 INDUCTOR CHIP 0µHFB414 1-414-234-22 INDUCTOR CHIP 0µH

<IC>

IC401 8-759-472-00 IC 74VHC14MTCXIC402 8-759-472-37 IC 74VHC240MTCXIC403 8-759-196-96 IC TC7SH08FU-TE85RIC404 8-759-541-25 IC M52758FPIC405 8-759-472-35 IC 74VHC221AMTCX

IC406 8-752-072-94 IC CXA1875AM-T4IC407 8-759-646-02 IC M52347FP-TEIC408 8-759-475-39 IC TC74LCX74FT(EL)IC409 8-759-645-12 IC AD9884AKS-140IC410 8-759-473-74 IC SN74CBTD3306PWR

IC411 8-759-472-14 IC 74VHC125MTCXIC412 8-759-563-33 IC CXD8774RIC413 8-759-660-44 IC THC63LVDM83A-TIC417 8-759-647-95 IC IP00C711IC418 8-759-082-58 IC TC7W08FU

IC419 8-759-582-91 IC S-80842ANNP-ED6-T2IC420 8-759-544-01 IC S-80828ANNP-EDR-T2IC421 8-759-475-35 IC TC74LCX04FT(EL)IC423 8-759-389-68 IC 74VHCT04MTCXIC424 8-759-655-76 IC MB90098APF-G-104-BND-ER

IC425 8-759-475-53 IC TC74LCX541FT(EL)IC426 8-759-557-86 IC NC7SZ86P5XIC427 8-759-648-10 IC HD64F2633TEIC428 8-759-058-58 IC TC7S04FU(TE85R)IC429 8-759-442-20 IC 24LC21AT/SN

IC430 8-759-277-63 IC TC7W14FU(TE12R)

<COIL>

L401 1-412-057-21 INDUCTOR CHIP 6.8µHL402 1-500-451-11 FERRITE 0µHL403 1-414-752-11 INDUCTOR 2.2µHL404 1-414-752-11 INDUCTOR 2.2µH

B

6-5VPL-CS1


<TRANSISTOR>

Q401 8-729-013-28 TRANSISTOR HN1B01FU-TE85RQ402 8-729-013-28 TRANSISTOR HN1B01FU-TE85RQ403 8-729-101-07 TRANSISTOR 2SB798-DLQ404 8-729-230-49 TRANSISTOR 2SC2712-YGQ405 8-729-140-63 TRANSISTOR 2SA1611-M5M6

<RESISTOR>

R401 1-216-805-11 RES,CHIP 47 5% 1/16WR402 1-216-809-11 RES,CHIP 100 5% 1/16WR403 1-216-821-11 RES,CHIP 1K 5% 1/16WR404 1-216-805-11 RES,CHIP 47 5% 1/16WR405 1-216-805-11 RES,CHIP 47 5% 1/16W

R406 1-216-805-11 RES,CHIP 47 5% 1/16WR407 1-216-809-11 RES,CHIP 100 5% 1/16WR408 1-216-833-91 RES,CHIP 10K 5% 1/16WR409 1-216-625-11 METAL CHIP 82 0.50% 1/10WR410 1-216-805-11 RES,CHIP 47 5% 1/16W

R411 1-218-668-11 METAL CHIP 100 5% 1/16WR412 1-218-716-11 METAL CHIP 10K 0.50% 1/16WR413 1-216-686-11 METAL CHIP 560 5% 1/16WR414 1-216-805-11 RES,CHIP 47 5% 1/16WR415 1-218-696-11 METAL CHIP 1.5K 0.50% 1/16W

R416 1-216-797-11 RES,CHIP 10 5% 1/16WR417 1-218-668-11 METAL CHIP 100 5% 1/16WR418 1-218-686-11 METAL CHIP 560 5% 1/16WR419 1-216-625-11 METAL CHIP 82 0.50% 1/10WR420 1-218-668-11 METAL CHIP 100 5% 1/16W

R421 1-218-686-11 METAL CHIP 560 5% 1/16WR422 1-216-833-91 RES,CHIP 10K 5% 1/16WR423 1-216-809-11 RES,CHIP 100 5% 1/16WR424 1-216-809-11 RES,CHIP 100 5% 1/16WR425 1-216-805-11 RES,CHIP 47 5% 1/16W

R426 1-216-625-11 METAL CHIP 82 0.50% 1/10WR427 1-216-833-91 RES,CHIP 10K 5% 1/16WR428 1-216-809-11 RES,CHIP 100 5% 1/16WR429 1-216-809-11 RES,CHIP 100 5% 1/16WR430 1-216-809-11 RES,CHIP 100 5% 1/16W

R431 1-216-833-91 RES,CHIP 10K 5% 1/16WR432 1-216-805-11 RES,CHIP 47 5% 1/16WR433 1-216-864-11 SHORT 0R434 1-218-708-11 METAL CHIP 4.7K 0.50% 1/16WR435 1-216-821-11 RES,CHIP 1K 5% 1/16W

R436 1-216-821-11 RES,CHIP 1K 5% 1/16WR437 1-216-841-11 RES,CHIP 47K 5% 1/16WR438 1-216-864-11 SHORT 0R439 1-216-805-11 RES,CHIP 47 5% 1/16WR440 1-216-821-11 RES,CHIP 1K 5% 1/16W

R443 1-216-827-11 RES,CHIP 3.3K 5% 1/16WR444 1-216-805-11 RES,CHIP 47 5% 1/16WR445 1-216-864-11 SHORT 0R446 1-218-732-11 METAL CHIP 47K 0.50% 1/16WR447 1-216-821-11 RES,CHIP 1K 5% 1/16W

R448 1-216-811-11 RES,CHIP 150 5% 1/16WR449 1-216-864-11 SHORT 0R450 1-216-864-11 SHORT 0R451 1-216-821-11 RES,CHIP 1K 5% 1/16WR452 1-216-821-11 RES,CHIP 1K 5% 1/16W


R459 1-216-833-91 RES,CHIP 10K 5% 1/16WR460 1-216-833-91 RES,CHIP 10K 5% 1/16W

R461 1-216-833-91 RES,CHIP 10K 5% 1/16WR462 1-216-833-91 RES,CHIP 10K 5% 1/16WR463 1-216-833-91 RES,CHIP 10K 5% 1/16W

R464 1-216-833-91 RES,CHIP 10K 5% 1/16WR465 1-216-833-91 RES,CHIP 10K 5% 1/16WR466 1-216-833-91 RES,CHIP 10K 5% 1/16WR467 1-216-833-91 RES,CHIP 10K 5% 1/16WR468 1-216-833-91 RES,CHIP 10K 5% 1/16W

R469 1-216-833-91 RES,CHIP 10K 5% 1/16WR470 1-216-827-11 RES,CHIP 3.3K 5% 1/16WR471 1-216-827-11 RES,CHIP 3.3K 5% 1/16WR472 1-216-809-11 RES,CHIP 100 5% 1/16WR473 1-216-833-91 RES,CHIP 10K 5% 1/16W

R474 1-218-694-11 METAL CHIP 1.2K 0.50% 1/16WR476 1-216-801-11 RES,CHIP 22 5% 1/16WR477 1-216-801-11 RES,CHIP 22 5% 1/16WR479 1-216-833-91 RES,CHIP 10K 5% 1/16WR480 1-216-839-11 RES,CHIP 33K 5% 1/16W

R481 1-216-839-11 RES,CHIP 33K 5% 1/16WR482 1-216-805-11 RES,CHIP 47 5% 1/16WR483 1-216-821-11 RES,CHIP 1K 5% 1/16WR484 1-216-811-11 RES,CHIP 150 5% 1/16WR485 1-216-841-11 RES,CHIP 47K 5% 1/16W

R486 1-216-808-11 RES,CHIP 82 5% 1/16WR487 1-216-805-11 RES,CHIP 47 5% 1/16WR488 1-218-675-11 METAL CHIP 200 0.50% 1/16WR489 1-216-833-91 RES,CHIP 10K 5% 1/16WR490 1-218-703-11 METAL CHIP 3K 0.50% 1/16W

R491 1-216-809-11 RES,CHIP 100 5% 1/16WR492 1-216-864-11 SHORT 0R495 1-216-821-11 RES,CHIP 1K 5% 1/16WR496 1-216-805-11 RES,CHIP 47 5% 1/16WR497 1-216-805-11 RES,CHIP 47 5% 1/16W

R499 1-216-805-11 RES,CHIP 47 5% 1/16WR500 1-216-864-11 SHORT 0R501 1-216-809-11 RES,CHIP 100 5% 1/16WR502 1-216-809-11 RES,CHIP 100 5% 1/16WR503 1-216-825-11 RES,CHIP 2.2K 5% 1/16W

R504 1-216-809-11 RES,CHIP 100 5% 1/16WR505 1-216-825-11 RES,CHIP 2.2K 5% 1/16WR506 1-216-809-11 RES,CHIP 100 5% 1/16WR507 1-216-809-11 RES,CHIP 100 5% 1/16WR508 1-216-809-11 RES,CHIP 100 5% 1/16W

R509 1-216-833-91 RES,CHIP 10K 5% 1/16WR510 1-216-833-91 RES,CHIP 10K 5% 1/16WR511 1-216-801-11 RES,CHIP 22 5% 1/16WR512 1-216-833-91 RES,CHIP 10K 5% 1/16WR513 1-216-833-91 RES,CHIP 10K 5% 1/16W

R514 1-216-833-91 RES,CHIP 10K 5% 1/16WR515 1-216-809-11 RES,CHIP 100 5% 1/16WR516 1-216-809-11 RES,CHIP 100 5% 1/16WR517 1-216-809-11 RES,CHIP 100 5% 1/16WR518 1-216-809-11 RES,CHIP 100 5% 1/16W

R519 1-216-833-91 RES,CHIP 10K 5% 1/16WR520 1-216-809-11 RES,CHIP 100 5% 1/16WR521 1-216-833-91 RES,CHIP 10K 5% 1/16WR522 1-216-809-11 RES,CHIP 100 5% 1/16WR523 1-216-809-11 RES,CHIP 100 5% 1/16W

R524 1-216-825-11 RES,CHIP 2.2K 5% 1/16WR525 1-216-825-11 RES,CHIP 2.2K 5% 1/16WR526 1-216-809-11 RES,CHIP 100 5% 1/16WR527 1-216-809-11 RES,CHIP 100 5% 1/16WR528 1-216-809-11 RES,CHIP 100 5% 1/16W

R529 1-216-833-91 RES,CHIP 10K 5% 1/16WR530 1-216-833-91 RES,CHIP 10K 5% 1/16WR531 1-216-809-11 RES,CHIP 100 5% 1/16W

B

6-6 VPL-CS1



R534 1-216-809-11 RES,CHIP 100 5% 1/16WR535 1-216-809-11 RES,CHIP 100 5% 1/16WR536 1-216-809-11 RES,CHIP 100 5% 1/16WR537 1-216-833-91 RES,CHIP 10K 5% 1/16WR538 1-216-833-91 RES,CHIP 10K 5% 1/16W

R539 1-216-833-91 RES,CHIP 10K 5% 1/16WR540 1-216-809-11 RES,CHIP 100 5% 1/16WR541 1-216-809-11 RES,CHIP 100 5% 1/16WR542 1-216-809-11 RES,CHIP 100 5% 1/16WR543 1-216-809-11 RES,CHIP 100 5% 1/16W


R549 1-216-809-11 RES,CHIP 100 5% 1/16WR550 1-216-833-91 RES,CHIP 10K 5% 1/16WR551 1-216-833-91 RES,CHIP 10K 5% 1/16WR553 1-216-809-11 RES,CHIP 100 5% 1/16WR554 1-216-833-91 RES,CHIP 10K 5% 1/16W

R555 1-216-825-11 RES,CHIP 2.2K 5% 1/16WR556 1-216-825-11 RES,CHIP 2.2K 5% 1/16WR557 1-216-821-11 RES,CHIP 1K 5% 1/16WR558 1-216-809-11 RES,CHIP 100 5% 1/16WR559 1-216-809-11 RES,CHIP 100 5% 1/16W

R560 1-216-833-91 RES,CHIP 10K 5% 1/16WR561 1-216-833-91 RES,CHIP 10K 5% 1/16WR562 1-216-809-11 RES,CHIP 100 5% 1/16WR563 1-216-833-91 RES,CHIP 10K 5% 1/16WR564 1-216-833-91 RES,CHIP 10K 5% 1/16W

R565 1-216-833-91 RES,CHIP 10K 5% 1/16WR566 1-216-829-11 RES,CHIP 4.7K 5% 1/16WR567 1-216-829-11 RES,CHIP 4.7K 5% 1/16WR568 1-216-833-91 RES,CHIP 10K 5% 1/16WR576 1-216-809-11 RES,CHIP 100 5% 1/16W

R577 1-216-809-11 RES,CHIP 100 5% 1/16WR583 1-216-809-11 RES,CHIP 100 5% 1/16WR584 1-216-833-91 RES,CHIP 10K 5% 1/16WR585 1-216-797-11 RES,CHIP 10 5% 1/16WR587 1-216-835-11 RES,CHIP 15K 5% 1/16W

R588 1-216-835-11 RES,CHIP 15K 5% 1/16WR589 1-216-841-11 RES,CHIP 47K 5% 1/16WR590 1-216-845-11 RES,CHIP 100K 5% 1/16WR591 1-216-805-11 RES,CHIP 47 5% 1/16WR592 1-216-805-11 RES,CHIP 47 5% 1/16W

R593 1-216-813-11 RES,CHIP 220 5% 1/16WR594 1-216-817-11 RES,CHIP 470 5% 1/16WR595 1-216-817-11 RES,CHIP 470 5% 1/16WR597 1-216-821-11 RES,CHIP 1K 5% 1/16W

<NETWORK>

RB401 1-233-576-11 RES, CHIP NET WORK 10 0RB402 1-233-576-11 RES, CHIP NET WORK 10 0RB403 1-233-576-11 RES, CHIP NET WORK 10 0RB404 1-233-576-11 RES, CHIP NET WORK 10 0RB405 1-233-576-11 RES, CHIP NET WORK 10 0


RB411 1-233-576-11 RES, CHIP NET WORK 10 0RB412 1-233-576-11 RES, CHIP NET WORK 10 0

RB413 1-233-576-11 RES, CHIP NET WORK 10 0RB414 1-233-576-11 RES, CHIP NET WORK 10 0RB415 1-233-576-11 RES, CHIP NET WORK 10 0

RB416 1-233-576-11 RES, CHIP NET WORK 10 0RB417 1-233-576-11 RES, CHIP NET WORK 10 0RB418 1-233-576-11 RES, CHIP NET WORK 10 0RB419 1-239-409-11 RES, CHIP NET WORK 47-3216RB520 1-233-576-11 RES, CHIP NET WORK 10 0


RB526 1-233-576-11 RES, CHIP NET WORK 10 0

<THERMISTOR>

TH201 1-809-020-11 THERMISTOR

<TEST PIN>

TP401 1-535-757-11 CHIP, CHECKERTP402 1-535-757-11 CHIP, CHECKERTP403 1-535-757-11 CHIP, CHECKERTP404 1-535-757-11 CHIP, CHECKERTP405 1-535-757-11 CHIP, CHECKER

TP406 1-535-757-11 CHIP, CHECKERTP407 1-535-757-11 CHIP, CHECKER

<CRYSTAL>

X401 1-781-420-21 OSCILLATOR, CRYSTAL (52MHz)X402 1-781-063-21 OSCILLATOR, CRYSTAL (70MHz)X403 1-781-659-21 VIBRATOR, CRYSTAL (12.288MHz)

*************************************************************

* A-1275-186-B QA COMPL**********************

<CAPACITOR>

C101 1-124-779-00 ELECT CHIP 10µF 20% 16VC102 1-126-204-11 ELECT CHIP 47µF 20% 16VC103 1-126-204-11 ELECT CHIP 47µF 20% 16VC104 1-113-985-11 TANTAL. CHIP 10µF 20% 20VC105 1-113-985-11 TANTAL. CHIP 10µF 20% 20V

C106 1-126-395-11 ELECT CHIP 22µF 20% 16VC107 1-126-395-11 ELECT CHIP 22µF 20% 16VC108 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC109 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC110 1-126-397-11 ELECT CHIP 33µF 20% 25V

C111 1-126-204-11 ELECT CHIP 47µF 20% 16VC112 1-126-395-11 ELECT CHIP 22µF 20% 16VC113 1-131-998-21 TANTALUM 82µF 20% 6.3VC114 1-164-182-11 CERAMIC CHIP 0.0033µF 10% 50VC115 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

C116 1-126-395-11 ELECT CHIP 22µF 20% 16VC117 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC118 1-119-667-11 CERAMIC CHIP 22µF 10VC119 1-113-500-11 TANTAL. CHIP 100µF 20% 10VC120 1-109-982-11 CERAMIC CHIP 1µF 10% 10V

C121 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC122 1-117-681-11 ELECT CHIP 100µF 20% 16VC123 1-119-667-11 CERAMIC CHIP 22µF 10V

B QA

6-7VPL-CS1


C124 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC125 1-163-251-11 CERAMIC CHIP 100PF 5% 50V

C126 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC127 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC128 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC129 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC130 1-126-205-11 ELECT CHIP 47µF 20% 6.3V

C131 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC132 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC133 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC134 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC135 1-109-982-11 CERAMIC CHIP 1µF 10% 10V

C136 1-117-370-11 CERAMIC CHIP 10µF 10VC137 1-163-251-11 CERAMIC CHIP 100PF 5% 50VC138 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC139 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC140 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50V


C148 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC149 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50VC150 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50VC151 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC152 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V


C158 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC159 1-163-239-11 CERAMIC CHIP 33PF 5% 50VC160 1-163-239-11 CERAMIC CHIP 33PF 5% 50VC161 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC162 1-124-778-00 ELECT CHIP 22µF 20% 6.3V

C163 1-124-778-00 ELECT CHIP 22µF 20% 6.3VC164 1-163-239-11 CERAMIC CHIP 33PF 5% 50VC165 1-163-239-11 CERAMIC CHIP 33PF 5% 50VC166 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC169 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

<CONNECTOR>

CN101 * 1-580-057-11 PIN, CONNECTOR (SMD) 4PCN102 * 1-760-388-11 CONNECTOR PIN(SMD) 9 PINCN103 * 1-785-306-21 CONNECTOR, BOARD TO BOARD 70PCN104 * 1-785-306-21 CONNECTOR, BOARD TO BOARD 70PCN105 * 1-793-798-21 CONNECTOR, BOARD TO BOARD

CN106 1-784-292-11 CONNECTOR, MINIATUREDIN 4PCN122 1-794-081-21 CONNECTOR, ROUND TYPE 6PCN123 * 1-580-056-21 PIN, CONNECTOR (SMD) 3P

<DIODE>

D101 8-719-158-15 DIODE RD5.6SBD102 8-719-158-15 DIODE RD5.6SBD103 8-719-158-15 DIODE RD5.6SBD104 8-719-158-15 DIODE RD5.6SBD105 8-719-158-37 DIODE RD9.1SB2

D106 8-719-158-37 DIODE RD9.1SB2D107 8-719-055-30 DIODE D1FS4A-TAD108 8-719-055-30 DIODE D1FS4A-TAD109 8-719-988-61 DIODE 1SS355TE-17D121 8-719-058-24 DIODE RB501V-40TE-17

D122 8-719-158-15 DIODE RD5.6SBD123 8-719-058-24 DIODE RB501V-40TE-17D124 8-719-422-12 DIODE MA8039D125 8-719-422-12 DIODE MA8039D126 8-719-158-15 DIODE RD5.6SB

D127 8-719-158-15 DIODE RD5.6SBD128 8-719-158-15 DIODE RD5.6SBD129 8-719-422-12 DIODE MA8039D130 8-719-422-12 DIODE MA8039D131 8-719-914-43 DIODE DAN202K

D133 8-719-058-24 DIODE RB501V-40TE-17D135 8-719-058-24 DIODE RB501V-40TE-17

<FERRITE BEAD>

FB121 1-414-234-22 INDUCTOR CHIP 0µHFB122 1-469-185-11 FERRITE 0µHFB123 1-414-234-22 INDUCTOR CHIP 0µHFB124 1-414-234-22 INDUCTOR CHIP 0µHFB125 1-469-185-11 FERRITE 0µH

FB126 1-216-295-91 SHORT 0FB127 1-469-185-11 FERRITE 0µHFB128 1-414-234-22 INDUCTOR CHIP 0µHFB129 1-414-234-22 INDUCTOR CHIP 0µHFB130 1-414-234-22 INDUCTOR CHIP 0µH

FB131 1-469-185-11 FERRITE 0µHFB132 1-414-234-22 INDUCTOR CHIP 0µHFB133 1-216-295-91 SHORT 0FB134 1-216-295-91 SHORT 0FB136 1-500-451-11 FERRITE 0µH

FB137 1-216-295-91 SHORT 0FB138 1-216-295-91 SHORT 0FB139 1-500-451-11 FERRITE 0µH

<FILTER>

FL101 1-239-899-21 FILTER, CHIP EMIFL102 1-239-899-21 FILTER, CHIP EMIFL103 1-239-899-21 FILTER, CHIP EMIFL104 1-239-899-21 FILTER, CHIP EMIFL105 1-239-899-21 FILTER, CHIP EMI

<IC>

IC101 8-759-460-72 IC BA033FP-E2IC102 8-759-460-72 IC BA033FP-E2IC103 8-759-335-28 IC TA78M09F(TE16L)IC104 8-759-157-17 IC PQ05SZ1UIC105 8-759-637-94 IC LT1376IS#TR

IC106 8-759-157-17 IC PQ05SZ1UIC107 8-759-066-55 IC TA75W393FUIC108 8-759-066-55 IC TA75W393FUIC121 8-719-066-43 DIODE GP1U28YIC122 8-759-654-25 IC RCV4-A1S-OTP

IC123 8-759-653-02 IC IRMFIC124 8-759-582-91 IC S-80842ANNP-ED6-T2IC125 8-759-666-01 IC ST72T631L4M1-101IC127 8-759-655-55 IC UPD72012GB-003-3B4IC128 8-759-655-59 IC UPD16875G-E2

<JACK>

J101 1-794-014-11 PIN, JACKJ102 1-566-822-21 JACKJ121 1-793-994-21 CONNECTOR, USBJ122 1-779-677-11 CONNECTOR, USB (B)

QA

6-8 VPL-CS1


<COIL>

L101 1-500-451-11 FERRITE 0µHL102 1-412-363-21 FERRITE 0µHL103 1-412-363-21 FERRITE 0µHL104 1-412-363-21 FERRITE 0µHL105 1-412-363-21 FERRITE 0µH

L106 1-412-363-21 FERRITE 0µHL107 1-412-363-21 FERRITE 0µHL108 1-409-529-41 INDUCTOR 10µHL109 1-414-753-91 INDUCTOR 4.7µHL131 1-216-295-91 SHORT 0

<TRANSISTOR>

Q102 8-729-230-49 TRANSISTOR 2SC2712-YGQ103 8-729-230-49 TRANSISTOR 2SC2712-YGQ104 8-729-230-49 TRANSISTOR 2SC2712-YGQ105 1-801-806-11 TRANSISTOR DTC144EKA 0Q106 1-801-806-11 TRANSISTOR DTC144EKA 0

Q107 8-729-216-22 TRANSISTOR 2SA1162-G

<RESISTOR>

R100 1-216-667-11 METAL CHIP 4.7K 0.50% 1/10WR101 1-216-025-91 RES,CHIP 100 5% 1/10WR102 1-216-624-11 METAL CHIP 75 0.50% 1/10WR103 1-216-624-11 METAL CHIP 75 0.50% 1/10WR104 1-216-624-11 METAL CHIP 75 0.50% 1/10W

R105 1-216-113-00 RES,CHIP 470K 5% 1/10WR106 1-216-113-00 RES,CHIP 470K 5% 1/10WR107 1-216-295-91 SHORT 0R108 1-216-049-91 RES,CHIP 1K 5% 1/10WR109 1-216-049-91 RES,CHIP 1K 5% 1/10W


R115 1-216-081-00 RES,CHIP 22K 5% 1/10WR116 1-216-081-00 RES,CHIP 22K 5% 1/10WR117 1-216-067-00 RES,CHIP 5.6K 5% 1/10WR118 1-216-657-11 METAL CHIP 1.8K 0.50% 1/10WR119 1-216-624-11 METAL CHIP 75 0.50% 1/10W

R120 1-216-091-00 RES,CHIP 56K 5% 1/10WR121 1-216-063-91 RES,CHIP 3.9K 5% 1/10WR122 1-216-067-00 RES,CHIP 5.6K 5% 1/10WR123 1-216-067-00 RES,CHIP 5.6K 5% 1/10WR124 1-216-077-91 RES,CHIP 15K 5% 1/10W

R125 1-216-077-91 RES,CHIP 15K 5% 1/10WR127 1-216-121-91 RES,CHIP 1M 5% 1/10WR128 1-216-025-91 RES,CHIP 100 5% 1/10WR129 1-216-049-91 RES,CHIP 1K 5% 1/10WR130 1-216-017-91 RES,CHIP 47 5% 1/10W

R131 1-216-017-91 RES,CHIP 47 5% 1/10WR133 1-216-091-00 RES,CHIP 56K 5% 1/10WR134 1-216-091-00 RES,CHIP 56K 5% 1/10WR135 1-216-073-00 RES,CHIP 10K 5% 1/10WR136 1-216-073-00 RES,CHIP 10K 5% 1/10W

R137 1-216-025-91 RES,CHIP 100 5% 1/10WR138 1-216-089-91 RES,CHIP 47K 5% 1/10WR139 1-216-025-91 RES,CHIP 100 5% 1/10WR140 1-216-025-91 RES,CHIP 100 5% 1/10WR141 1-216-089-91 RES,CHIP 47K 5% 1/10W

R142 1-216-114-00 RES,CHIP 510K 5% 1/10WR143 1-216-073-00 RES,CHIP 10K 5% 1/10WR144 1-216-025-91 RES,CHIP 100 5% 1/10W

R145 1-216-114-00 RES,CHIP 510K 5% 1/10WR146 1-216-073-00 RES,CHIP 10K 5% 1/10W

R147 1-216-065-91 RES,CHIP 4.7K 5% 1/10WR148 1-216-077-91 RES,CHIP 15K 5% 1/10WR149 1-216-077-91 RES,CHIP 15K 5% 1/10WR150 1-216-295-91 SHORT 0R151 1-216-295-91 SHORT 0

R152 1-216-053-00 RES,CHIP 1.5K 5% 1/10WR153 1-216-121-91 RES,CHIP 1M 5% 1/10WR154 1-216-085-00 RES,CHIP 33K 5% 1/10WR155 1-216-073-00 RES,CHIP 10K 5% 1/10WR156 1-216-025-91 RES,CHIP 100 5% 1/10W

R157 1-216-025-91 RES,CHIP 100 5% 1/10WR158 1-216-025-91 RES,CHIP 100 5% 1/10WR159 1-216-025-91 RES,CHIP 100 5% 1/10WR160 1-216-025-91 RES,CHIP 100 5% 1/10WR161 1-216-049-91 RES,CHIP 1K 5% 1/10W


R167 1-216-083-00 RES,CHIP 27K 5% 1/10WR168 1-216-073-00 RES,CHIP 10K 5% 1/10WR170 1-216-005-00 RES,CHIP 15 5% 1/10WR171 1-216-005-00 RES,CHIP 15 5% 1/10WR172 1-216-005-00 RES,CHIP 15 5% 1/10W




R189 1-216-295-91 SHORT 0R192 1-216-073-00 RES,CHIP 10K 5% 1/10WR193 1-216-053-00 RES,CHIP 1.5K 5% 1/10WR194 1-216-025-91 RES,CHIP 100 5% 1/10WR195 1-216-057-00 RES,CHIP 2.2K 5% 1/10W

R197 1-216-073-00 RES,CHIP 10K 5% 1/10WR198 1-216-053-00 RES,CHIP 1.5K 5% 1/10WR199 1-216-073-00 RES,CHIP 10K 5% 1/10W

<SWITCH>

S101 1-762-984-11 SWITCH, PUSH (LAMP COVER)S202 1-771-897-11 SWITCH, MICRO (FILTER COVER)

<CRYSTAL>

X101 1-781-163-11 VIBRATOR, OSCILLATOR (24MHz)X102 1-767-340-11 VIBRATOR, CRYSTAL (4MHz)X103 1-781-163-11 VIBRATOR, OSCILLATOR (24MHz)

*************************************************************

QA

6-9VPL-CS1


* A-1316-492-A GA COMPL**********************

1-533-223-11 HOLDER, FUSE (F601)1-900-251-41 CONNECTOR ASSY 3P

* 4-074-436-01 INSULATION PLATE (B)* 4-074-437-01 INSULATION PLATE (A)* 4-374-846-01 COVER, CAPACITOR,CAP TYPE

4-382-854-01 SCREW (M3X8), P, SW (+)

<CAPACITOR>

C601 ! 1-113-907-51 CERAMIC 0.0022µF 20% 250VC602 ! 1-115-166-11 FILM 0.22µF 20% 275VC603 ! 1-113-907-51 CERAMIC 0.0022µF 20% 250VC604 1-135-449-11 ELECT 220µF 20% 450VC608 1-107-906-11 ELECT 10µF 20% 50V

C609 1-107-792-11 CERAMIC 100PF 5% 1KVC610 1-129-720-00 FILM 0.033µF 5% 630VC611 1-115-785-91 ELECT 470µF 20% 25VC612 1-107-889-11 ELECT 220µF 20% 25VC615 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50V

C617 1-107-888-11 ELECT 47µF 20% 25VC618 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50VC619 1-130-202-00 FILM 0.022µF 5% 400VC620 1-115-742-11 ELECT 0.0027F 20% 10VC621 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50V

C623 1-107-909-11 ELECT 47µF 20% 16VC624 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50VC625 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50VC626 1-163-003-11 CERAMIC CHIP 330PF 10% 50VC627 1-164-492-11 CERAMIC CHIP 0.15µF 10% 16V

C628 1-165-319-11 CERAMIC CHIP 0.1µF 50VC629 1-107-888-11 ELECT 47µF 20% 25VC631 1-163-113-00 CERAMIC CHIP 68PF 5% 50VC632 1-164-492-11 CERAMIC CHIP 0.15µF 10% 16VC633 1-163-133-00 CERAMIC CHIP 470PF 5% 50V

C634 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50VC635 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC636 1-126-795-11 ELECT 10µF 20% 50VC637 ! 1-113-511-11 FILM 0.47µF 20% 275VC638 1-117-228-11 MYLAR 2.2µF 10% 450V

C671 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC672 1-126-795-11 ELECT 10µF 20% 50VC673 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50VC674 1-126-786-11 ELECT 47µF 20% 16V

<CONNECTOR>

CN601 * 1-691-960-11 PIN, CONNECTOR (PC BOARD) 3PCN604 * 1-794-043-11 CONNECTOR,BOARD TO BOARD 6PCN605 * 1-564-706-11 PIN, CONNECTOR (SMALL TYPE) 4PCN606 * 1-774-249-11 CONNECTOR, BOARD TO BOARD 10P

<DIODE>

D601 ! 8-719-066-75 DIODE D6SB80D602 8-719-060-06 DIODE FSF10A60D603 8-719-055-30 DIODE D1FS4A-TAD604 8-719-055-30 DIODE D1FS4A-TAD605 8-719-066-76 DIODE TF861S

D606 8-719-110-53 DIODE RD20ESB2D607 8-719-059-23 DIODE P6KE200AG23D608 8-719-961-04 DIODE RGP10JD609 8-719-510-41 DIODE D10SC9MD610 8-719-300-33 DIODE RU-3AM

D611 8-719-071-97 DIODE P6KE350AG23D612 8-719-106-31 DIODE RD8.2M-T1B1D613 8-719-071-97 DIODE P6KE350AG23D614 8-719-073-37 DIODE P6KE300AG23D615 8-719-053-50 DIODE FCQ20A06

D616 8-719-051-96 DIODE FMG-G2CSD617 8-719-053-50 DIODE FCQ20A06D618 8-719-071-97 DIODE P6KE350AG23D619 8-719-106-31 DIODE RD8.2M-T1B1D620 8-719-071-97 DIODE P6KE350AG23

D621 8-719-055-33 DIODE D1FL40D622 8-719-107-43 DIODE RD24M-B2

<FUSE>

F601 ! 1-576-233-11 FUSE (H.B.C.) (6.3A/250V)

<IC>

IC602 8-759-388-23 IC TL431BCDR2IC603 8-759-487-72 IC TOP222Y-BBIC604 8-759-470-64 IC TOP223Y-BBIC605 8-759-583-06 IC FA5331M-TE1IC671 8-759-388-23 IC TL431BCDR2

IC672 8-759-460-74 IC BA05FP-E2

<COIL>

L601 ! 1-431-419-11 TRANSFORMER,LINE FILTERL602 1-416-754-21 INDUCTOR 0µHL603 1-406-976-11 INDUCTOR 68µHL604 1-413-090-00 INDUCTOR 110µH

<PHOTO COUPLER>

PH601 8-749-010-64 PHOTO COUPLER PC123F2PH602 8-749-010-64 PHOTO COUPLER PC123F2PH603 8-749-010-64 PHOTO COUPLER PC123F2

<IC LINK>

PS601 ! 1-576-124-11 LINK, IC (2A)

<TRANSISTOR>

Q601 8-729-043-15 TRANSISTOR 2SK3013F-2Q602 8-729-922-39 TRANSISTOR 2SD2144S-VQ603 8-729-230-49 TRANSISTOR 2SC2712-YGQ604 8-729-230-49 TRANSISTOR 2SC2712-YGQ671 8-729-230-49 TRANSISTOR 2SC2712-YG

<RESISTOR>

R601 ! 1-202-847-00 SOLID 560K 20% 1/2WR602 1-216-003-11 RES,CHIP 12 5% 1/10WR603 1-216-077-91 RES,CHIP 15K 5% 1/10WR604 1-219-363-11 FUSIBLE 5.6 5% 5W FR605 1-217-156-00 REGISTER 0.22 10% 5W F

R606 1-260-324-11 CARBON 470 5% 1/2WR607 1-216-097-91 RES,CHIP 100K 5% 1/10WR608 1-249-429-11 CARBON 10K 5% 1/4W FR609 1-249-389-11 CARBON 4.7 5% 1/4W FR610 1-215-903-11 METAL OXIDE 68K 5% 2W F

R611 1-220-270-11 RES,CHIP 390 5% 1/2WR613 1-249-389-11 CARBON 4.7 5% 1/4W FR615 1-216-671-11 METAL CHIP 6.8K 0.50% 1/10WR617 1-220-337-11 RES,CHIP 270K 5% 1/2W

GA

6-10 VPL-CS1


R618 1-216-667-11 METAL CHIP 4.7K 0.50% 1/10W

R620 1-216-033-00 RES,CHIP 220 5% 1/10WR621 1-216-311-00 RES,CHIP 6.8 5% 1/10WR622 1-220-267-11 RES,CHIP 180 5% 1/2WR623 1-216-049-91 RES,CHIP 1K 5% 1/10WR625 1-220-337-11 RES,CHIP 270K 5% 1/2W

R626 1-216-075-00 RES,CHIP 12K 5% 1/10WR627 1-216-025-91 RES,CHIP 100 5% 1/10WR628 1-216-689-11 RES,CHIP 39K 5% 1/10WR629 1-215-927-00 METAL OXIDE 47K 5% 3W FR630 1-215-927-00 METAL OXIDE 47K 5% 3W F

R631 1-216-311-00 RES,CHIP 6.8 5% 1/10WR632 1-216-049-91 RES,CHIP 1K 5% 1/10WR633 1-216-033-00 RES,CHIP 220 5% 1/10WR634 1-216-629-11 METAL CHIP 120 0.50% 1/10WR635 1-216-053-00 RES,CHIP 1.5K 5% 1/10W

R636 1-216-085-00 RES,CHIP 33K 5% 1/10WR637 1-216-101-00 RES,CHIP 150K 5% 1/10WR638 1-216-073-00 RES,CHIP 10K 5% 1/10WR639 1-216-659-11 METAL CHIP 2.2K 0.50% 1/10WR640 1-216-659-11 METAL CHIP 2.2K 0.50% 1/10W

R641 1-216-655-11 METAL CHIP 1.5K 0.50% 1/10WR642 1-220-335-11 RES,CHIP 180K 5% 1/2WR643 1-220-337-11 RES,CHIP 270K 5% 1/2WR644 1-220-336-11 RES,CHIP 220K 5% 1/2WR645 1-220-337-11 RES,CHIP 270K 5% 1/2W

R646 1-220-335-11 RES,CHIP 180K 5% 1/2WR647 1-220-335-11 RES,CHIP 180K 5% 1/2WR648 1-216-075-00 RES,CHIP 12K 5% 1/10WR649 1-216-025-91 RES,CHIP 100 5% 1/10WR650 1-216-005-00 RES,CHIP 15 5% 1/10W

R651 1-216-687-11 METAL CHIP 33K 0.50% 1/10WR652 1-216-689-11 RES,CHIP 39K 5% 1/10WR653 1-216-065-91 RES,CHIP 4.7K 5% 1/10WR654 1-216-667-11 METAL CHIP 4.7K 0.50% 1/10WR671 1-216-603-11 METAL CHIP 10 0.50% 1/10W

R672 1-216-077-91 RES,CHIP 15K 5% 1/10WR673 1-220-270-11 RES,CHIP 390 5% 1/2WR674 1-220-267-11 RES,CHIP 180 5% 1/2WR675 1-216-691-11 METAL CHIP 47K 0.50% 1/10WR676 1-216-671-11 METAL CHIP 6.8K 0.50% 1/10W

R677 1-216-085-00 RES,CHIP 33K 5% 1/10WR678 1-216-093-91 RES,CHIP 68K 5% 1/10WR679 1-216-667-11 METAL CHIP 4.7K 0.50% 1/10W

<TRANSFORMER>

T601 ! 1-435-199-11 TRANSFORMER,CONVERTER (SRT)T602 ! 1-435-198-11 TRANSFORMER,CONVERTER (PIT)

<VARISTOR>

VD602 ! 1-801-073-41 VARISTOR ERZV14D471VD604 1-803-136-11 VARISTOR ZP260

*************************************************************

* A-1316-492-A GBA COMPL**********************

1-533-223-11 HOLDER, FUSE (F601)* 4-074-436-01 INSULATION PLATE (B)* 4-074-437-01 INSULATION PLATE (A)* 4-374-846-01 COVER, CAPACITOR,CAP TYPE

4-382-854-01 SCREW (M3X8), P, SW (+)

<CAPACITOR>

C676 1-126-382-11 ELECT 100µF 20% 16VC677 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50VC678 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50VC679 1-126-796-11 ELECT 22µF 20% 35VC680 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50V

C681 1-115-784-11 ELECT 270µF 20% 25VC682 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50VC683 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50VC684 1-124-589-11 ELECT 47µF 20% 16VC718 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50V

C719 1-126-789-11 ELECT 33µF 20% 25V

<CONNECTOR>

CN671 1-794-042-11 CONNECTOR, BOARD TO BOARDCN674 1-564-707-11 PIN, CONNECTOR (SMALL TYPE) 5PCN675 * 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3PCN676 * 1-564-705-11 PIN, CONNECTOR (SMALL TYPE) 3P

<DIODE>

D672 8-719-914-43 DIODE DAN202KD673 8-719-055-30 DIODE D1FS4A-TAD674 8-719-055-30 DIODE D1FS4A-TAD675 8-719-055-30 DIODE D1FS4A-TA

<IC>

IC673 8-759-650-39 IC LT1374IS8IC704 8-759-388-31 IC PQ20VZ1U

<COIL>

L671 1-406-659-11 INDUCTOR 10µH

<TRANSISTOR>

Q672 8-729-230-49 TRANSISTOR 2SC2712-YGQ673 8-729-230-49 TRANSISTOR 2SC2712-YG

<RESISTOR>

R680 1-216-049-91 RES,CHIP 1K 5% 1/10WR681 1-216-025-91 RES,CHIP 100 5% 1/10WR682 1-216-073-00 RES,CHIP 10K 5% 1/10WR683 1-216-025-91 RES,CHIP 100 5% 1/10WR686 1-216-089-91 RES,CHIP 47K 5% 1/10W

R687 1-216-075-00 RES,CHIP 12K 5% 1/10WR688 1-216-073-00 RES,CHIP 10K 5% 1/10WR689 1-216-081-00 RES,CHIP 22K 5% 1/10WR694 1-216-081-00 RES,CHIP 22K 5% 1/10WR696 1-216-683-11 METAL CHIP 22K 0.50% 1/10W

R697 1-216-697-91 METAL CHIP 82K 0.50% 1/10WR698 1-216-681-91 METAL CHIP 18K 0.50% 1/10WR699 1-216-695-11 METAL CHIP 68K 0.50% 1/10WR700 1-216-295-91 SHORT 0R701 1-216-667-11 METAL CHIP 4.7K 0.50% 1/10W

R716 1-216-683-11 METAL CHIP 22K 0.50% 1/10WR717 1-216-675-91 METAL CHIP 10K 0.50% 1/10WR718 1-216-665-11 METAL CHIP 3.9K 0.50% 1/10WR719 1-216-665-11 METAL CHIP 3.9K 0.50% 1/10WR720 1-216-675-91 METAL CHIP 10K 0.50% 1/10W

R721 1-216-675-91 METAL CHIP 10K 0.50% 1/10W

GA GBA GBB

6-11VPL-CS1


*************************************************************

* A-1316-492-A GBB COMPL**********************

1-533-223-11 HOLDER, FUSE (F601)* 4-074-436-01 INSULATION PLATE (B)* 4-074-437-01 INSULATION PLATE (A)* 4-374-846-01 COVER, CAPACITOR,CAP TYPE

4-382-854-01 SCREW (M3X8), P, SW (+)

<CAPACITOR>

C701 1-115-339-11 CERAMIC CHIP 0.1µF 10% 50VC702 1-126-789-11 ELECT 33µF 20% 25VC740 1-117-354-91 ELECT 330µF 20% 35VC742 1-117-316-91 ELECT 470µF 20% 25VC776 1-126-786-11 ELECT 47µF 20% 16V

C777 1-124-589-11 ELECT 47µF 20% 16VC778 1-128-526-11 ELECT 100µF 20% 16V

<CONNECTOR>

CN702 * 1-774-246-11 CONNECTOR, BOARD TO BOARD 10PCN706 * 1-564-710-11 PIN, CONNECTOR (SMALL TYPE) 8PCN707 * 1-564-711-11 PIN, CONNECTOR (SMALL TYPE) 9P

<DIODE>

D715 8-719-510-41 DIODE D10SC9MD727 8-719-073-52 DIODE D2FS6-TAD728 8-719-073-52 DIODE D2FS6-TAD736 8-719-110-36 DIODE RD13ESB2

<IC>

IC701 8-759-388-31 IC PQ20VZ1U

<COIL>

L702 1-406-977-61 INDUCTOR 100µHL703 1-416-208-11 INDUCTOR 150µHL707 1-412-525-31 INDUCTOR 10µH

<TRANSISTOR>

Q710 8-729-807-51 TRANSISTOR 2SD1623-S

<RESISTOR>

R706 1-216-653-11 METAL CHIP 1.2K 0.50% 1/10WR707 1-216-679-11 METAL CHIP 15K 0.50% 1/10WR781 1-216-671-11 METAL CHIP 6.8K 0.50% 1/10WR782 1-216-675-91 METAL CHIP 10K 0.50% 1/10WR784 1-218-235-11 RES,CHIP 82 5% 1/2W

R785 1-220-274-11 RES,CHIP 1.2K 5% 1/2WR787 1-220-274-11 RES,CHIP 1.2K 5% 1/2WR788 1-220-274-11 RES,CHIP 1.2K 5% 1/2WR789 1-220-274-11 RES,CHIP 1.2K 5% 1/2W

*************************************************************

* A-1335-123-A C COMPL**********************

<CAPACITOR>

C801 1-135-346-21 TANTALUM 39µF 20% 16VC802 1-128-400-11 ELECT CHIP 47µF 20% 25VC803 1-128-400-11 ELECT CHIP 47µF 20% 25VC804 1-117-681-11 ELECT CHIP 100µF 20% 16VC805 1-128-400-11 ELECT CHIP 47µF 20% 25V

C807 1-115-340-11 CERAMIC CHIP 0.22µF 10% 25VC808 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC812 1-115-340-11 CERAMIC CHIP 0.22µF 10% 25VC813 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC814 1-126-205-11 ELECT CHIP 47µF 20% 6.3V

C816 1-124-779-00 ELECT CHIP 10µF 20% 16VC817 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC818 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC819 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC820 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50V

C822 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC824 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC825 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC826 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC827 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50V

C828 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC829 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC830 1-126-391-11 ELECT CHIP 47µF 20% 6.3VC831 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC832 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50V


C841 1-124-779-00 ELECT CHIP 10µF 20% 16VC842 1-124-779-00 ELECT CHIP 10µF 20% 16VC843 1-124-779-00 ELECT CHIP 10µF 20% 16VC845 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50VC846 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50V

C850 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC851 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC852 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50VC853 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC854 1-126-205-11 ELECT CHIP 47µF 20% 6.3V

C855 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC856 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC857 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC858 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC859 1-126-205-11 ELECT CHIP 47µF 20% 6.3V

C860 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC861 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC862 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC863 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC864 1-126-205-11 ELECT CHIP 47µF 20% 6.3V

C865 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC867 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC868 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC869 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC870 1-128-400-11 ELECT CHIP 47µF 20% 25V


C879 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50V

GBB C

6-12 VPL-CS1


C880 1-128-400-11 ELECT CHIP 47µF 20% 25VC881 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC882 1-117-681-11 ELECT CHIP 100µF 20% 16VC883 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V


C892 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50VC893 1-163-009-11 CERAMIC CHIP 0.001µF 10% 50VC894 1-164-005-11 CERAMIC CHIP 0.47µF 25VC895 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC896 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

C897 1-128-400-11 ELECT CHIP 47µF 20% 25VC898 1-128-400-11 ELECT CHIP 47µF 20% 25VC899 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC900 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC902 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

C904 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50VC905 1-163-227-11 CERAMIC CHIP 10PF 0.5PF 50VC906 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC907 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC909 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

C911 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC912 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC913 1-128-400-11 ELECT CHIP 47µF 20% 25VC914 1-117-681-11 ELECT CHIP 100µF 20% 16VC915 1-128-400-11 ELECT CHIP 47µF 20% 25V

C916 1-117-681-11 ELECT CHIP 100µF 20% 16VC917 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC918 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC919 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC920 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

C923 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC925 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC926 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC927 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC928 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

C931 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC932 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC933 1-164-005-11 CERAMIC CHIP 0.47µF 25VC934 1-164-005-11 CERAMIC CHIP 0.47µF 25VC935 1-104-915-11 TANTAL. CHIP 2.2µF 20% 20V

C936 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC937 1-128-394-11 ELECT CHIP 220µF 20% 10VC938 1-124-779-00 ELECT CHIP 10µF 20% 16VC939 1-113-985-11 TANTAL. CHIP 10µF 20% 20VC940 1-109-982-11 CERAMIC CHIP 1µF 10% 10V

C941 1-128-394-11 ELECT CHIP 220µF 20% 10VC942 1-126-396-11 ELECT CHIP 47µF 20% 16VC943 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC944 1-104-915-11 TANTAL. CHIP 2.2µF 20% 20VC945 1-104-760-11 CERAMIC CHIP 0.047µF 10% 50V

C946 1-104-760-11 CERAMIC CHIP 0.047µF 10% 50VC947 1-115-340-11 CERAMIC CHIP 0.22µF 10% 25VC948 1-115-340-11 CERAMIC CHIP 0.22µF 10% 25VC949 1-117-681-11 ELECT CHIP 100µF 20% 16VC950 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

C951 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC952 1-113-985-11 TANTAL. CHIP 10µF 20% 20VC953 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC954 1-163-021-91 CERAMIC CHIP 0.01µF 10% 50VC955 1-124-779-00 ELECT CHIP 10µF 20% 16V

C958 1-117-370-11 CERAMIC CHIP 10µF 10VC959 1-117-370-11 CERAMIC CHIP 10µF 10V

C960 1-117-370-11 CERAMIC CHIP 10µF 10VC961 1-109-982-11 CERAMIC CHIP 1µF 10% 10VC962 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V


C968 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC969 1-126-205-11 ELECT CHIP 47µF 20% 6.3VC970 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25VC971 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

<CONNECTOR>

CN801 * 1-793-798-21 CONNECTOR, BOARD TO BOARDCN802 * 1-691-551-11 PIN, CONNECTOR (SMD) 8PCN803 1-774-932-21 CONNECTOR, FFC/FPC (ZIF) 32PCN804 * 1-580-789-21 PIN, CONNECTOR (SMD) 6PCN805 * 1-580-055-21 PIN, CONNECTOR (SMD) 2P

CN806 * 1-580-056-21 PIN, CONNECTOR (SMD) 3PCN807 1-569-775-11 PIN, CONNECTOR (SMD) 5PCN808 * 1-764-007-11 PIN, CONNECTOR (SMD) 12PCN809 * 1-569-775-21 PIN, CONNECTOR (SMD) 5PCN810 * 1-691-551-11 PIN, CONNECTOR (SMD) 8P

CN811 1-766-479-21 CONNECTOR, FFC/FPC (ZIF) 24PCN812 1-766-479-21 CONNECTOR, FFC/FPC (ZIF) 24PCN813 1-766-479-21 CONNECTOR, FFC/FPC (ZIF) 24PCN814 * 1-580-057-11 PIN, CONNECTOR (SMD) 4P

<DIODE>

D801 8-719-976-99 DIODE DTZ5.1BD802 8-719-976-99 DIODE DTZ5.1BD803 8-719-976-99 DIODE DTZ5.1BD804 8-719-976-99 DIODE DTZ5.1BD805 8-719-976-99 DIODE DTZ5.1B

D806 8-719-976-99 DIODE DTZ5.1BD807 8-719-976-99 DIODE DTZ5.1BD812 8-719-976-99 DIODE DTZ5.1BD813 8-719-976-99 DIODE DTZ5.1BD814 8-719-976-99 DIODE DTZ5.1B

<FERRITE BEAD>


FB806 1-414-234-22 INDUCTOR CHIP 0µHFB807 1-414-234-22 INDUCTOR CHIP 0µHFB808 1-414-234-22 INDUCTOR CHIP 0µHFB809 1-414-950-21 FERRITE 0µHFB810 1-414-950-21 FERRITE 0µH



FB821 1-414-234-22 INDUCTOR CHIP 0µHFB822 1-414-234-22 INDUCTOR CHIP 0µH

C

6-13VPL-CS1


FB823 1-414-234-22 INDUCTOR CHIP 0µHFB824 1-414-234-22 INDUCTOR CHIP 0µH

<FILTER>

FL801 1-239-899-21 FILTER, CHIP EMIFL802 1-234-011-11 FILTER, EMIFL803 1-234-011-11 FILTER, EMIFL804 1-234-011-11 FILTER, EMI

<IC>

IC801 8-759-259-77 IC PQ20VZ5UIC802 8-759-460-81 IC BA12FP-E2IC803 8-759-584-86 IC M52749FP-TPIC804 8-759-523-81 IC TC74VHC08FT(EL)IC805 8-759-660-42 IC THC63LVDF84A-T

IC806 8-759-645-13 IC ADV7123KST140IC807 8-719-985-01 DIODE LM385M-1.2IC808 8-759-491-46 IC TC74VHCT04AFT(EL)IC809 8-759-658-73 IC ISPLSI1016E-80LT44-SX1697IC810 8-759-491-46 IC TC74VHCT04AFT(EL)

IC811 8-759-482-35 IC MC100ELT20DR2IC812 8-759-592-44 IC TC7SZ04FU(TE85R)IC813 8-759-064-36 IC MB88346BPFVIC814 8-759-544-55 IC MAX4066CEE#NAME?IC815 8-752-080-99 IC CXA2112R

IC817 8-752-080-99 IC CXA2112RIC818 8-752-080-99 IC CXA2112RIC819 8-759-702-02 IC NJM062MIC820 8-752-091-06 IC CXA1846BN-T4IC821 8-759-702-02 IC NJM062M

IC822 8-759-491-46 IC TC74VHCT04AFT(EL)

<COIL>

L801 1-410-393-11 INDUCTOR CHIP 100µHL802 1-410-381-11 INDUCTOR CHIP 10µHL803 1-414-752-11 INDUCTOR 2.2µHL804 1-414-752-11 INDUCTOR 2.2µHL806 1-410-369-11 INDUCTOR CHIP 1µH

L807 1-410-369-11 INDUCTOR CHIP 1µHL808 1-410-369-11 INDUCTOR CHIP 1µHL809 1-410-369-11 INDUCTOR CHIP 1µHL810 1-410-369-11 INDUCTOR CHIP 1µHL811 1-410-369-11 INDUCTOR CHIP 1µH

L812 1-410-377-31 INDUCTOR CHIP 4.7µHL813 1-414-752-11 INDUCTOR 2.2µHL814 1-469-524-91 INDUCTOR 4.7µH

<TRANSISTOR>

Q801 8-729-112-65 TRANSISTOR 2SA1462-Y33Q802 8-729-216-22 TRANSISTOR 2SA1162-GQ803 8-729-216-22 TRANSISTOR 2SA1162-GQ804 8-729-013-28 TRANSISTOR HN1B01FU-TE85RQ805 8-729-013-28 TRANSISTOR HN1B01FU-TE85R

Q806 8-729-013-28 TRANSISTOR HN1B01FU-TE85RQ807 8-729-013-28 TRANSISTOR HN1B01FU-TE85RQ808 8-729-013-28 TRANSISTOR HN1B01FU-TE85RQ809 8-729-013-28 TRANSISTOR HN1B01FU-TE85RQ810 8-729-216-22 TRANSISTOR 2SA1162-G

Q811 8-729-230-49 TRANSISTOR 2SC2712-YGQ812 1-801-806-11 TRANSISTOR DTC144EKA0Q813 1-801-806-11 TRANSISTOR DTC144EKA0Q814 8-729-112-65 TRANSISTOR 2SA1462-Y33Q815 8-729-112-65 TRANSISTOR 2SA1462-Y33

Q816 1-801-806-11 TRANSISTOR DTC144EKA0Q817 8-729-112-65 TRANSISTOR 2SA1462-Y33

<RESISTOR>

R801 1-216-073-00 RES,CHIP 10K 5% 1/10WR802 1-216-682-11 METAL CHIP 20K 0.50% 1/10WR803 1-216-673-11 METAL CHIP 8.2K 0.50% 1/10WR804 1-216-295-91 SHORT 0R805 1-216-065-91 RES,CHIP 4.7K 5% 1/10W

R806 1-216-644-11 METAL CHIP 510 0.50% 1/10WR807 1-216-017-91 RES,CHIP 47 5% 1/10WR809 1-216-295-91 SHORT 0R810 1-216-017-91 RES,CHIP 47 5% 1/10WR811 1-216-017-91 RES,CHIP 47 5% 1/10W

R812 1-216-017-91 RES,CHIP 47 5% 1/10WR813 1-216-017-91 RES,CHIP 47 5% 1/10WR815 1-216-651-11 METAL CHIP 1K 0.50% 1/10WR816 1-216-025-91 RES,CHIP 100 5% 1/10WR817 1-216-049-91 RES,CHIP 1K 5% 1/10W

R820 1-216-025-91 RES,CHIP 100 5% 1/10WR821 1-216-661-11 METAL CHIP 2.7K 0.50% 1/10WR822 1-216-065-91 RES,CHIP 4.7K 5% 1/10WR823 1-216-065-91 RES,CHIP 4.7K 5% 1/10WR824 1-216-025-91 RES,CHIP 100 5% 1/10W


R830 1-216-009-91 RES,CHIP 22 5% 1/10WR831 1-216-624-11 METAL CHIP 75 0.50% 1/10WR832 1-216-624-11 METAL CHIP 75 0.50% 1/10WR833 1-216-113-00 RES,CHIP 470K 5% 1/10WR836 1-216-025-91 RES,CHIP 100 5% 1/10W

R837 1-216-049-91 RES,CHIP 1K 5% 1/10WR838 1-216-295-91 SHORT 0R839 1-216-049-91 RES,CHIP 1K 5% 1/10WR841 1-216-624-11 METAL CHIP 75 0.50% 1/10WR842 1-216-065-91 RES,CHIP 4.7K 5% 1/10W

R843 1-216-037-00 RES,CHIP 330 5% 1/10WR844 1-216-037-00 RES,CHIP 330 5% 1/10WR845 1-216-295-91 SHORT 0R846 1-216-037-00 RES,CHIP 330 5% 1/10WR847 1-216-037-00 RES,CHIP 330 5% 1/10W

R848 1-216-649-11 METAL CHIP 820 0.50% 1/10WR849 1-216-662-11 METAL CHIP 3K 0.50% 1/10WR850 1-216-025-91 RES,CHIP 100 5% 1/10WR851 1-216-025-91 RES,CHIP 100 5% 1/10WR852 1-216-025-91 RES,CHIP 100 5% 1/10W

R853 1-216-295-91 SHORT 0R854 1-216-295-91 SHORT 0R855 1-216-017-91 RES,CHIP 47 5% 1/10WR856 1-216-017-91 RES,CHIP 47 5% 1/10WR857 1-216-017-91 RES,CHIP 47 5% 1/10W

R858 1-216-017-91 RES,CHIP 47 5% 1/10WR859 1-216-049-91 RES,CHIP 1K 5% 1/10WR860 1-216-017-91 RES,CHIP 47 5% 1/10WR861 1-216-017-91 RES,CHIP 47 5% 1/10WR862 1-216-017-91 RES,CHIP 47 5% 1/10W

R863 1-216-295-91 SHORT 0R864 1-216-049-91 RES,CHIP 1K 5% 1/10WR865 1-216-295-91 SHORT 0R866 1-216-025-91 RES,CHIP 100 5% 1/10WR867 1-216-017-91 RES,CHIP 47 5% 1/10W

R868 1-216-025-91 RES,CHIP 100 5% 1/10W

C

6-14 VPL-CS1


R869 1-216-017-91 RES,CHIP 47 5% 1/10WR870 1-216-025-91 RES,CHIP 100 5% 1/10WR871 1-216-017-91 RES,CHIP 47 5% 1/10WR872 1-216-295-91 SHORT 0

R873 1-216-025-91 RES,CHIP 100 5% 1/10WR874 1-216-295-91 SHORT 0R875 1-216-295-91 SHORT 0R876 1-216-009-91 RES,CHIP 22 5% 1/10WR877 1-216-037-00 RES,CHIP 330 5% 1/10W

R878 1-216-037-00 RES,CHIP 330 5% 1/10WR879 1-216-009-91 RES,CHIP 22 5% 1/10WR880 1-216-073-00 RES,CHIP 10K 5% 1/10WR881 1-216-295-91 SHORT 0R882 1-216-025-91 RES,CHIP 100 5% 1/10W

R883 1-216-295-91 SHORT 0R884 1-216-067-00 RES,CHIP 5.6K 5% 1/10WR885 1-216-025-91 RES,CHIP 100 5% 1/10WR887 1-216-077-91 RES,CHIP 15K 5% 1/10WR889 1-216-025-91 RES,CHIP 100 5% 1/10W

R890 1-216-025-91 RES,CHIP 100 5% 1/10WR891 1-216-025-91 RES,CHIP 100 5% 1/10WR892 1-216-065-91 RES,CHIP 4.7K 5% 1/10WR893 1-216-025-91 RES,CHIP 100 5% 1/10WR894 1-216-025-91 RES,CHIP 100 5% 1/10W

R895 1-216-025-91 RES,CHIP 100 5% 1/10WR896 1-216-065-91 RES,CHIP 4.7K 5% 1/10WR900 1-216-295-91 SHORT 0R901 1-216-041-00 RES,CHIP 470 5% 1/10WR902 1-216-025-91 RES,CHIP 100 5% 1/10W

R903 1-216-025-91 RES,CHIP 100 5% 1/10WR904 1-216-025-91 RES,CHIP 100 5% 1/10WR905 1-216-025-91 RES,CHIP 100 5% 1/10WR906 1-216-295-91 SHORT 0R907 1-216-065-91 RES,CHIP 4.7K 5% 1/10W

R908 1-216-041-00 RES,CHIP 470 5% 1/10WR909 1-216-065-91 RES,CHIP 4.7K 5% 1/10WR910 1-216-295-91 SHORT 0R911 1-216-041-00 RES,CHIP 470 5% 1/10WR912 1-216-041-00 RES,CHIP 470 5% 1/10W

R913 1-216-041-00 RES,CHIP 470 5% 1/10WR914 1-216-685-11 METAL CHIP 27K 0.50% 1/10WR915 1-216-295-91 SHORT 0R916 1-216-295-91 SHORT 0R917 1-216-001-00 RES,CHIP 10 5% 1/10W

R918 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR919 1-216-001-00 RES,CHIP 10 5% 1/10WR920 1-216-025-91 RES,CHIP 100 5% 1/10WR921 1-216-298-00 RES,CHIP 2.2 5% 1/10WR922 1-216-295-91 SHORT 0

R923 1-216-001-00 RES,CHIP 10 5% 1/10WR924 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR925 1-216-298-00 RES,CHIP 2.2 5% 1/10WR926 1-216-001-00 RES,CHIP 10 5% 1/10WR927 1-216-073-00 RES,CHIP 10K 5% 1/10W

R929 1-216-001-00 RES,CHIP 10 5% 1/10WR930 1-216-001-00 RES,CHIP 10 5% 1/10WR931 1-216-295-91 SHORT 0R932 1-216-073-00 RES,CHIP 10K 5% 1/10WR933 1-216-057-00 RES,CHIP 2.2K 5% 1/10W

R934 1-216-025-91 RES,CHIP 100 5% 1/10WR935 1-216-298-00 RES,CHIP 2.2 5% 1/10WR936 1-216-295-91 SHORT 0R937 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR938 1-216-298-00 RES,CHIP 2.2 5% 1/10W


R943 1-216-295-91 SHORT 0R944 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR945 1-216-025-91 RES,CHIP 100 5% 1/10W

R946 1-216-298-00 RES,CHIP 2.2 5% 1/10WR947 1-216-295-91 SHORT 0R948 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR949 1-216-298-00 RES,CHIP 2.2 5% 1/10WR950 1-216-685-11 METAL CHIP 27K 0.50% 1/10W

R951 1-216-685-11 METAL CHIP 27K 0.50% 1/10WR952 1-216-295-91 SHORT 0R953 1-216-295-91 SHORT 0R954 1-216-001-00 RES,CHIP 10 5% 1/10WR955 1-216-001-00 RES,CHIP 10 5% 1/10W


R961 1-216-001-00 RES,CHIP 10 5% 1/10WR962 1-216-001-00 RES,CHIP 10 5% 1/10WR963 1-216-001-00 RES,CHIP 10 5% 1/10WR964 1-216-073-00 RES,CHIP 10K 5% 1/10WR965 1-216-073-00 RES,CHIP 10K 5% 1/10W

R966 1-216-001-00 RES,CHIP 10 5% 1/10WR967 1-216-001-00 RES,CHIP 10 5% 1/10WR968 1-216-073-00 RES,CHIP 10K 5% 1/10WR969 1-216-073-00 RES,CHIP 10K 5% 1/10WR970 1-216-295-91 SHORT 0

R971 1-216-089-91 RES,CHIP 47K 5% 1/10WR972 1-216-295-91 SHORT 0R973 1-216-071-00 RES,CHIP 8.2K 5% 1/10WR975 1-216-295-91 SHORT 0R976 1-216-071-00 RES,CHIP 8.2K 5% 1/10W

R977 1-216-089-91 RES,CHIP 47K 5% 1/10WR978 1-217-671-11 RES,CHIP 1 5% 1/10WR979 1-217-671-11 RES,CHIP 1 5% 1/10WR980 1-216-067-00 RES,CHIP 5.6K 5% 1/10WR981 1-216-067-00 RES,CHIP 5.6K 5% 1/10W

R982 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR983 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR984 1-216-033-00 RES,CHIP 220 5% 1/10WR985 1-216-033-00 RES,CHIP 220 5% 1/10WR986 1-216-295-91 SHORT 0

R988 1-216-295-91 SHORT 0R989 1-216-025-91 RES,CHIP 100 5% 1/10WR990 1-216-025-91 RES,CHIP 100 5% 1/10WR991 1-216-025-91 RES,CHIP 100 5% 1/10WR992 1-216-053-00 RES,CHIP 1.5K 5% 1/10W

R993 1-216-061-00 RES,CHIP 3.3K 5% 1/10WR994 1-216-097-91 RES,CHIP 100K 5% 1/10WR995 1-216-073-00 RES,CHIP 10K 5% 1/10WR996 1-216-649-11 METAL CHIP 820 0.50% 1/10WR997 1-216-662-11 METAL CHIP 3K 0.50% 1/10W

R998 1-216-649-11 METAL CHIP 820 0.50% 1/10WR999 1-216-662-11 METAL CHIP 3K 0.50% 1/10WR1000 1-216-041-00 RES,CHIP 470 5% 1/10WR1001 1-216-041-00 RES,CHIP 470 5% 1/10WR1002 1-216-041-00 RES,CHIP 470 5% 1/10W

R1003 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR1004 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR1005 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR1006 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR1007 1-216-057-00 RES,CHIP 2.2K 5% 1/10W

R1008 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR1009 1-216-631-11 METAL CHIP 150 0.50% 1/10WR1010 1-216-631-11 METAL CHIP 150 0.50% 1/10W

C

6-15VPL-CS1


R1011 1-216-631-11 METAL CHIP 150 0.50% 1/10WR1012 1-216-073-00 RES,CHIP 10K 5% 1/10W


R1018 1-216-009-91 RES,CHIP 22 5% 1/10WR1019 1-216-295-91 SHORT 0R1020 1-216-295-91 SHORT 0R1021 1-216-043-91 RES,CHIP 560 5% 1/10WR1022 1-216-061-00 RES,CHIP 3.3K 5% 1/10W

<THERMISTOR>

TH801 1-808-656-11 THERMISTORTH802 1-808-656-11 THERMISTOR

<TEST PIN>




TP816 1-535-757-11 CHIP, CHECKERTP817 1-535-757-11 CHIP, CHECKER

*************************************************************

* A-1375-195-A H COMPL**********************

<CAPACITOR>

C001 1-164-004-11 CERAMIC CHIP 0.1µF 10% 25V

<CONNECTOR>


<DIODE>

D001 8-719-045-61 DIODE SEC1901C (LAMP-LED)D002 8-719-045-61 DIODE SEC1901C (TEMP-LED)D003 8-719-045-53 DIODE SEC1801C (POWER-SAVE)D004 8-719-914-43 DIODE DAN202KD005 8-719-914-43 DIODE DAN202K

D006 8-719-914-43 DIODE DAN202KD007 8-719-914-43 DIODE DAN202KD008 8-719-045-51 DIODE SEC2422C (POWER/STBY)D009 8-719-914-44 DIODE DAP202KD010 8-719-914-44 DIODE DAP202K

D011 8-719-914-44 DIODE DAP202KD012 8-719-914-44 DIODE DAP202K

<TRANSISTOR>

Q001 8-729-027-38 TRANSISTOR DTA144EKA0

<RESISTOR>


R006 1-216-069-00 RES,CHIP 6.8K 5% 1/10WR007 1-216-063-91 RES,CHIP 3.9K 5% 1/10WR008 1-216-059-00 RES,CHIP 2.7K 5% 1/10WR009 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR010 1-216-053-00 RES,CHIP 1.5K 5% 1/10W

R011 1-216-055-00 RES,CHIP 1.8K 5% 1/10WR012 1-216-037-00 RES,CHIP 330 5% 1/10WR013 1-216-059-00 RES,CHIP 2.7K 5% 1/10WR014 1-216-057-00 RES,CHIP 2.2K 5% 1/10WR015 1-216-053-00 RES,CHIP 1.5K 5% 1/10W

R016 1-216-055-00 RES,CHIP 1.8K 5% 1/10W

<SWITCH>

S001 1-771-105-11 SWITCH, TACTILE (LEFT)S002 1-771-105-11 SWITCH, TACTILE (RIGHT)S003 1-771-105-11 SWITCH, TACTILE (DOWN)S004 1-771-105-11 SWITCH, TACTILE (UP)S005 1-771-105-11 SWITCH, TACTILE (ENTER)

S006 1-771-105-11 SWITCH, TACTILE (MENU)S007 1-771-105-11 SWITCH, TACTILE (INPUT)S008 1-771-105-11 SWITCH, TACTILE (POWER)S009 1-771-105-11 SWITCH, TACTILE (APA)S010 1-771-105-11 SWITCH, TACTILE (VOL+)

S011 1-771-105-11 SWITCH, TACTILE (VOL–)S012 1-771-105-11 SWITCH, TACTILE (RESET)

*************************************************************

* A-1390-984-A NF MOUNT**********************

<CAPACITOR>

C071 1-113-985-11 TANTAL. CHIP 10µF 20% 20V

<CONNECTOR>


<IC>

IC071 8-749-012-17 IC RS-140-T

<RESISTOR>


*************************************************************

HC NF

6-16 VPL-CS1

MISCELLANEOUS**********************

A-150-163-6A OPTICS BLOCK ASSY! 1-251-382-12 INLET, AC 3P(WITH NOISE FILTE)

1-468-457-11 POWER, LAMP1-500-082-11 CLAMP, SLEEVE FERRITE1-500-657-11 CORE, FERRIET1-529-544-11 SPEAKER (3.6CM)

1-763-172-11 FAN, DC1-763-474-11 FAN1-900-222-47 CONNECTOR ASSY 2P1-900-251-42 CONNECTOR ASSY, MINI MICRO 4P

*************************************************************

ACCESSORIES**********************

! 1-534-827-14 CORD, POWER (7A/125V)! 1-777-649-11 CORD, POWER (10A/250V)! 1-782-929-11 CORD, POWER SUPPLY (BS 3P)

(10A/250V)1-418-804-11 REMOTE COMMANDER (RM-PJM1)1-790-081-21 CABLE, USB

4-074-278-11 OPERATING, INSTRUCTIONS(ENGLISH/FRENCH/SPANISH)

4-074-278-21 OPERATING, INSTRUCTIONS(GERMAN/ITALIAN)

4-074-279-01 QUICK REFERENCE CARD (ENGLISH/FRENCH/SPANISH/GERMAN/ITALIAN/CHINESE)

* 4-074-444-01 BAG, CARRY4-074-717-01 FILTER

9-885-000-19 BATTERY COVER (FOR RM-PJM1)

Ref.No. Part No. Description Remark

7-1 7-1

A B C D E F G H

1

2

3

4

5

VPL-CS1

Section 7Block Diagrams

OVERALL BLOCK

OVERALL OVERALL

VIDEO

SW

R-Y,Y,B-Y

V-R,V-G,V-B

IC404

A/D

CONV.

IC409

R,G,B

CONV.

D/A

IC406

IC402

INV

SW

G SYNC

SEPA.

IC407

Y

HSI,VSI

IC424

OSD

SCAN

CONV.

IC417

SDRAM

IC416

IC415

IC414

R,G,B LDVS

RECEIVER

IC413

TA,TB,TC,TD

SDAT

LAMP ON

RXD

TXD

KEY

LED

A-L,A-R

POWER CONT

FAN CONT

U-DA,U-CL

LAMPC,FANC,SIRES

V-R,V-G,V-B

R-Y,Y,B-Y

FLASH

B

INPUT-A

AC IN REGULATING

POWER-FACTOR

CONTROL

IC605

FAN CONT

POWER CONT

FAN+B

SUB+5V

AUDIO+B

+16.5V

GA,GBA,GBB

IR

RECEIVER

IC071

NF

SIRCS-NF

C

TIMING

GEN.

R DA,G DA,B DA RGB

AMP

IC809

CONV.

D/A

IC806 IC803

VISCA

RA,RB,RC,RD LDVS

RECEIVER

IC805R,G,B LCD

DRIVER

IC818

12CH D/A

CONV.

IC813

PLDINV.

IC810

IC808

IC817

IC815

M.OUT

PANEL

LCD

LAMP

SP

L,RAMPVOLUME

IC827 IC819,821

AUDIO

MATRIX

KEY

H

2

34

1

J101

CN416

C,Y,S

VIDEO

R-Y,Y,B-Y

V-R,V-G,V-B

A-L,A-R

VIDEO

CN122

DAT/R1

J122

J121

QA

A-R

A-L

SIRES

LAMPC

SW

REMOTE

IC123

SIRCS

RECEIVER

IC121

MOUSE

CONT.

IC122USB HUB CTRL

DS2+,DS2-

US+,US-

DS1+,DS1-

DS3+,DS3-

IC125

RESET

IC124

IC128

FANC

COLOR

DECODER

IC301

IC201

D/A

CONV.

C,Y

S

IC221C,Y

AD

COMB

DIGITAL

FILTER

IC271

DECODER

RGB

BA

AUDIO IN

CONTROL

R AD,G AD B,AD

MAIN CPU

IC427

DC-DC CONV.

&

SW REG.

FAN1

FAN2

USB5V

MAIN CPU,A/D CONVERTER,SCAN CONVERTER,SDRAM,LVDS RECEIVER,RGB INPUT,SYNC SEP 12CH DAC,TIMING GENERATER

LCD DRIVER,RGB AMP,AUDIO AMP,

(KEY INPUT,LED)

COLOR DECODER,RGB DECODER,D COMB

A/B USB CONNECTORVIDEO INPUT,MOUSE CONNECTOR,

IC127

USB POWER

SUPP

USB PJ

CTRL

RECEIVEFRONT SIRCS

DC-DC CONVERTERFAN DRIVE

7-2 7-2

A B C D E F G H

1

2

3

4

5

VPL-CS1

NF, QA BLOCK

NF, QA NF, QA

A

(VIDEO INPUT,MOUSE CONNECTOR,USB CONNECTOR,USB CONTROL)

TO GA BOARD

CN605

USB- 32

MOUSE CONTROLLER

IC122

PB710

X101

24MHz

VIDEO

4

1

3

2

CN416

AUDIO IN

QA

CN122

J102

C

Y

S

J101

C

BUFFER

Q102

Q103

BUFFER

Y

S SEL

S-Y

S-C

1

2

CN101

C-V

Q104

BUFFER

CV

SUB +5V

3.3V REG

IC101

I O

G

5

1

CN707

TO GBB BOARD

B

CN102

G

OI

IC103

9V REG

6

2

+16.5V

+6V

AUDIO +B

A +9V

SUB +3.3V A +3.3V

G

OI

IC102

3.3V REG5V-3

5V REG

IC104

G

A +5V

OI I O

D +5V

G

IC106

5V REG

IC105

3.3V REG

2 VIN 3VSW

D +3.3V

IC107

57

6

2

31

76

5

21

3

IC108

OUTVCC

XXXXXX

IC071

NF(FRONT SIRCS RECEIVE)

CN071

2

1

SIRCS-NF

SUB +5V 1

2

CN123

SUB +5V

SIRCS-NF

5V

IC121

SIRCS RECEIVE5V

OUTVCC

REMOTE SW

2

3

5

IRIN1

7

6

IRIN2

IREN1

IREN2

IROUT

IC123

NR ON

NF ON

SIRCS

CLK

USB5V

DAT/R124 PA2

28 PA1

31USB+

X22

3 X1

J122

3.3V-1

US+

US-

US-

US+

TP102

TP101

J121

1

2

4

3

DS1-

DS1+

A-R

A-L

A-GND

IC127

USB HUB CONTROL

13

12

25

26

4MHz

X102

40

41

33

327

8

10

9

14

15

6

42

DS2-

DS2+

US-

US+

DS1-

DS1+

DS3-

DS3+

SW

3.3V-1Q106,107

OUTVDD2

RESET

IC124

1

5V

USB POWER SUPP

IC128

4

1

2

3

CTL2

CTL1

FLG1

FLG2 OUT1 5

8OUT2

SW

Q105

USB5V

IC125

USB RJ CONTROL

7 PC0

OSCIN3

2 OSCOUT

PA128

PA224

24MHz

X103

USBDP 32

31USBDM

8 RESET

U-DA

U-CL

USB REQ

DS3-

DS3+

CN104

B21

A21

A19

B19

I

TO BA BOARD

CN201

Y

C

A15

B15

S-IN

A23

B23

VIDEO

A7

B7

F-DA

A8

B8

F-CL

A9

B9

F+5V

A10

B10

SDA

A11

B11

SCL

A12

B12

V-VD

A13

B13

V-HD

A14

B14

V-CLP

A16

B16

15K-CS

A17

B17

PAL-V

A25

B25

B-Y

A27

B27

R-Y

A29

B29

Y

A31

B31

V-R

A33

B35

A35

B33

V-B

V-G

CN103

B33

A33

B27

A27

A29

A28

B29

B28

B31

A31

B26

A26

B25

A25

B24

A24

B22

A22

A23

B23

SDA

SCL

F+5V

F-DA

F-CL

PWR PROT

NR ON

U-DA

LAMPC

A34

B34

A35

B35

CN401

TO B BOARD

G

SIRES

NF ON

U-CL

FAN-C

A-R

A-GND

A-L

S101S202

CN105

A25

A2

B2

USB REQ

R-Y

Y

B4

A4

A6

B6

B-Y

A8

B8

V-R

A10

B10

V-G

A12

B12

V-B

A14

B14

PAL-V

A16

B16

15K-CS

A18

B18

V-HD

A19

B19

V-VD

A20

B20

V-CLP

H

TO B BOARD

CN402

S-VIDEO

MOUSE

B TYPE

USB

USB

A TYPE

7-3 7-3

A B C D E F G H

1

2

3

4

5

VPL-CS1

BA BA

BA BLOCK

Q271

BA

CN201

B25

A25 B-Y

I

(COLOR DECODER,RGB DECODER,D COMB)

R-YA27

B27

YA29

B29

A31 V-R

B31

B33

A33 V-G

A35

B35

V-B

VIDEO

Y

C

B23

A23

B21

A21

A19

B19

15K-CS

PAL-V

A16

B16

A17

B17

V-VD

B12

A12

TO QA BOARD

CN104

B-Y

BUFFER

BUFFER

R-Y

Q272

Q273

Y

BUFFER

V-R

TP271 TP272

V-G

TP273

V-B

R-OUT44

39 Y2-IN

38 RY2-IN

37 BY2-IN

RGB DECODER

G-OUT45

B-OUT46

IC271

35Y1-IN

34RY1-IN

BY1-IN 33

14 SCL

SDA13SDA

SCL

21Y OUT

CB OUT 22

CR OUT 23

COLOR DECODER

IC301

C243

IC302

Q303

Q302

V-HDA13

B13

V-CLPA14

B14

INV

INV

S-IN

SDA

SCL

B10

A10

B11

A11

A15

B15

B7

A7 F-DA

B8

A8 F-CL

F+5VA9

B9

CVBS/Y2S-Y

44

1 CVBS/Y1VIDEO

19 Y115K-CS

41 CVBS/Y3PALV

13 SCL

14 SDA

4 VS

9 HS

10 SCP

38 XTAL

SCL

SDA

D/A CONVERTER

IC201

10 SW3 3DAC 4INPUTA/VIDEO

X301

16.2MHz

SW29

SW11

SDL

14 SDA

15

DAC 0 7

6DAC 1

5DAC 2

SCL 6VCC8

NVM

IC202

5SDA

SDA

SCL

30YUV-SW

VB-Y

VR-Y

VY

VR-Y

VB-Y

VY

COMB Y 5

7COMB C/FORCED S

46SFC OUT

INPUT/VIDEO

VEH 3

VEH 2

VEH 1

CVBS OUT(2VPPP) 3 BUFFER

Y

BUFFER

C

BUFFER

Q221

Q229

Q227

FL221

FILTER

1 6

Q222

BUFFER

IC221

DIGITAL COMB FILTER

2 ADIN

FIN37

AYO916

Q228FILTER

FL223

ACO716

Q226FILTER

FL222

BUFFER

Y

BUFFER

C

20 VEH 3

21 VEH 2

22 VEH 1

26 NTPL1

S-C

41

3

NTPL1

7-4 7-4

A B C D E F G H

1

2

3

4

5

VPL-CS1

B B

B(MAIN CPU,A/D CONVERTER,CSAN CONVERTER,SDRAM,LVDS RECEIVER,RGB INPUT,SYNC SEP)

CN404

R-Y

Y

B-Y

PAL V

VIDEO SW

IN2(R)11

IC404

OUT(R) 35

R

TP404

V-R

V-G13

V-B16

IN2(G)

IN2(B)

7

5

2

IN1(B)

IN1(G)

IN1(R)

OUT(G) 30

OUT(B) 27

TP403

G

TP402

B

R

G

B

SW 19

CLAMP

H.POL

V.POL

8

4

6

G SYNC SEPA

V IN

GREEN IN

C/H 17

VD 13

18

19

IC407

HD 14

IC401(5/6)

11 10

1

D/A CONVERTER

IC406

SW1

DAC2 5SW02

SCL15

14 SDASDA

SCL

DAC3 4

IC401(6/6)

12 13

IC402

INV SW

1 15

19

6 9

4 3

11 18

2 7

13 14

17 5

16

5

IC429

DDC

76 SCL

SDAVCLK

IC403

2 6

IC403

17

V-HD

15K-CS

V-VD

(2/6)(1/6)

1 2 43

(3/6)

65

IC401IC401IC4011

24

IC403

IC401(4/6)

9 8

TP401

VSI

MONO MULTI

9

IC405

12

1 4

2A

1A

2Q

1QV-CLP

HSI

TP405

VSI

HSI

IC409

7 R IN

A/D CONVERTER

105

112DRA0

DRA7

DRB7

DRB0 102

95

R

G15 G IN

B22 B IN

R OLD0-7

R NEW0-7

G OLD0-7

G NEW0-7

DGB7

DGB0

DGA7

DGA0

75

82

92

85

B OLD0-7

B NEW0-7

DBB7

DBB0

DBA7

DBA0

55

62

72

65

IC410

BUFFER

2A

1A

5

2 3

2B

1B

6

SDA

SCL29 SDA

30 SCL

VSI

40 HSYNC

28 CLAMP

41 COASTCOAST

CLAMP

HSI

117HSOUT

DATACK

DATACK/

115

116

VSITP406

PICLK

VDD OUT

3.3V-252MHz XTAL

X401 IC421

INV

2A

1A

3

1 2

2Y

1Y

4

13

5

6A

3A

6Y

3Y 6

1270MHz XTAL

OUTVDD

3.3V-2X402

POCLK

MEMCLK

IC423

6A13

9

5

1

4A

3A

1A

105Y

4Y

3Y

2Y

8

4

6

INVERTER

POHS

POVS

HSYNC10

25

OSD

IC424

5 DCLK1

1 CS

11 VSYNC

OSD CS 164

SDAT(OSD) 5 152 SIN

OSD ON

SCLK(OSD)

7 13

6 14

12

3

DISP

SCLK

182RESN13

15

RESET

BISYTRE

IC425

OSDDT3

OSDDT226

OSDDT127

OSDDT028

OSDEN242

1

IC426

4

10 ZOOM

30 IRQ0

116 RXD3

33 TIOCB2

19 PB6

31 TCLKC

17 PB4

POVS

SRX

HSI

VSI

IC427

MAIN CPU

22 TXD2(FWR)SDAT(OSD)

SCLK(OSD)SCLK24

OSD CSPD043

RESNP71111

OSD ONP72112

TREP73113

4

8

7

3

6

2

RES

MD2

CN406

FLASH MD1

RXD

FWR

TXD

RES

MD2

MD1

RXD2(FWR)

FWE

120

71

67 WDTOVF

119

23

74

RESET

OUT

5V-1

VDD

3.3V-1IC420

2 1

OUT2 VDD

IC419

RESET

1

CPU RES

IC418

6

53

Q403,404

RES

SW8

F-CL

VCCSDA

SCLF-DA

6

5

IC422

NVM

F+5V

35PSAVE LED

PE1

PE2 36LAMP LED

PE3 37TEMP LED

PE4 38POWER LED

AN0/P40 39KEY0

AN1/P41 94

AN2/P42 95LAMP TEMP

AN3/P43 96PANEL TEMP

KEY1

SDA-IN 8SDA

SDA-OUT 6SCL

SCL 4U-CL

SCL1 57U-DA

SDA1 55NR OFF

PB2 15NF OFF

PB1 14

PC2 3F-DA

PC1 2F-CL

PC0 1SIRCS

PB0 12FILTER COVER

AN8/P90 101

LAMP COVER102

PWR PROT114

AN9/P91

P74

SCK3

100

115

117TXD3

PD6

PD5

RXD4 60

DA0/AN6/P46

AN5/P45

AN4/P44

TXD4

99

98

97

61

50

49

PD7

PD4

51

48

PE6

PE5

40

39

DAC CS

SCLK

SDAT

FAN CONT1

LAMP SENS

RXD

EXT SW

AUDIO CS

POWER ON

DA1/AN7/P47

LAMP ON

TXD

AUDIO MUTE

FAN CONT2

FAN PROT

SC RST

SC CS

P70 110

PD2

PD3

46

47APA CS

45PD1USB REQ

INPUT-A

7-5 7-5

A B C D E F G H

1

2

3

4

5

VPL-CS1

B BLOCK

B B

B1

B5

A2

A3

B2

A4

B3

A5

B4

A16

B17

A17

B19

A19

B21

A21

B23

A23

B24

A24

RXD

TXD

EXT SW

POWER ON

LAMP ON

FAN CONT2

FAN CONT1

FAN PROT

LAMP SENS

AUDIO MUTE

AUDIO CS

A-R

A-G

A-L

SDAT

SCLK

DAC CS

F

TO

CN403

B25

A25

CN801

C BOARD

A-L

A-G

A-R

SIRCS

A35

B35

A34

B34

A33

B33

A31

B31

A29

B29

A28

B28

B27

A27LAMP COVER

FILTER COVER

U-DA

NR OFF

U-CL

NF OFF

PWR PROT

B26

A26F-CL

B25

A25F-DA

B23

A23SCL

B22

A22SDA

F+5V

CN401

A24

B24

G

QA BOARD

CN103

TO

E

TO

C BOARD

CN803

PSAVE LED

POWER LED 1

TEMP LED 2

LAMP LED 3

KEY1

4

KEY0

6

LAMP TEMP

8

PANEL TEMP

10

12

SDA 14

SCL 16

TD-

TD+

19

18

TCLK-

TCLK+

22

21

TC-

TC+

25

24

TB-

TB+

28

27

TA-

CN405

TA+ 30

31

TO

H

CN105

QA BOARD

USB REQ A25

V-CLP B20

A20

V-VD B19

A19

V-HD B18

A18

15K-CS B16

A16

PAL V B14

A14

V-B B12

A12

V-G B10

A10

V-R B8

A8

B-Y B6

A6

Y B4

A4

A2

B2R-Y

CN402

IC415

SDRAM

MD32-47

(SAME AS IC416)

MD16-31

IC414

SDRAM

(SAME AS IC416)

MEMCLK

MD0-15

DQ15 49

48

46

45

43

42

40

39

12

11

9

8

6

5

3

2DQ0

35 CLK

36 UDQA

19 BA

18 CS

17 RAS

16 CAS

15 WE

14 LDQM

A0

A10/AP20

32

31

30

29

28

27

24

23

22

IC416

21

SDRAM

SDOUT 77

TD-

TD+

TCLK-

TCLK+

TC-

TC+

TB-

TB+

37

38

39

40

41

42

45

46

TA+47

TA-48

SCLK

APA CS

SDAT

SRX

BUFFER

3

6

8

2Y

1Y

3Y

4Y 11

2A

1A

3A

2

5

9

12 4A

IC411

79 SCLK

80 SCSIN

78 SDIN

B OLD7-0

DIN1019

13

DIN1711

DIN27

DIN20

B NEW7-0

10

1 CLKPICLK

41 VDXPIVS

65 HDXINPIHS

POFLD

3

IC412

APA

FLDIN69

28

31

30

POHS

POCLK

POVS

52

54

56

2

4

6

7

8

10

12

14

16

28

20

22

25

27

LDVS RECEIVER

IC413

B00-09

POFLDPOFLD 117

PIFLD 250

POD29 159

155

152

POD20 148

145

142

140

138

POD10

135

132

G00-09

POD19

R00-09

DQM1

79CASCAS

78RASRAS

77MWRWE

76BA0BA

4UDQM

LDQM3DQM0

CSCS 2

MA0-10

MD0-47

MA10 92

86

83

80MA0

POD9 131

129

127

125

122

120

POD0 118

SRX

POVS

POHS

POCLK

116

115

105

POVS

POHS

POCLK

1 SO

OSD-SIG

OSDDT3112 OSDDT3

OSDEN

OSDDT0

OSDDT1

OSDDT2

107

111

110

106

OSDDT2

OSDDT1

OSDDT0

OSDEN

SCLK

IC428

42252 SCLK

254

253

100 RST

SI

SS

SC RST

SDAT

SC CS

PICLK

248 PICLKPICLK

246 PIHSPIHS

PIVS

PIHS1D

2D

2

12 9

1Q

2Q

6

3

11

1CK

2CK

D-FF

IC408

PIVSPIVS245

B NEW0-7

PID47244

238

PID40235

B OLD0-7

PID39234

PID32227

G NEW0-7

G OLD0-7

226

PID24

PID31

218

225

223

PID23217

214

211

B AD

PID16208

G AD

73

68

71

55

58

61

64

66

51

53

45

48

38

41

31

34

24

27

20

17

14

10

12

7MD0

MD47

IC417

SCAN CONVERTER

R AD

207

203

201

199

PID8

PID15

PID7

PID0

197

190

198

R OLD0-7

R NEW0-7

7-6 7-6

A B C D E F G H

1

2

3

4

5

VPL-CS1

C, H C, H

B3

B5

A3

CN801

LAMP ON

LAMP SENS

POWER ON

FAN CONT1

FAN PROT

A4

B4

A5

FAN CONT2

IC804(1/4)

65

IC804(3/4)

108

9

1

FUSE

TEMP

CN805

2

L CONT OUT

L CONT IN

3

1

CN806

SCI

FLAG BALLAST

1

3

LAMP

2

1

CN807

FAN PROT

POWER CONT

FAN CONT1 3

FAN CONT2 4

C

TO

GBA BOARD

CN674CN809

EXT SW

TXD

RXD

5

3

2

VISCA

CN814

SP-R

SP-L

1

3L

R

EXT SW

TXD

RXD

A2

B2

B1

20 15A-L

A-R1

A-LB23

A-LA23

A-RA25

APCE7

SDAT8

A-SCLK9

VOLUME

IC820

6

53

AUDIO AMP

IC821

6

IC819

AUDIO AMP

7

81

MUTE

Q812,813

Q810,811

MUTE

AUDIO CSA17

A-RB25

APCE

SDATA21 SDAT

SDATB21

SCLK

B19

A19A-SCLK

SCLKIC804(4/4)

13

1211

D-SCLK

DALDB17 DAC CS

AUDIO MUTEA16

F

B BOARD

TO

CN403

CN803

LAMP TEMP

LED TEMP

23

1SWITCH

Q816

TH802

LCD

TH801

LAMP

POWER LED32

TEMP LED31

LAMP LED30

PSAVE LED29

KEY127

25 KEY0

3

7

4

PSAVE LED

KEY1

KEY0

CN808

8LAMP LED

9TEMP LED

10POWER LED

4

3

7

8

9

10

CN1001

S001-008

KEY-MATRIX

S009-012

KEY-MATRIX

D001-003

LED

Q001

SWITCH

POWER/STBY

D008

4

3

2

VD

B

R

G

CN804

1

HD 5

M.OUT

SCL

SDA

17

19

RD-

RD+

14

15

RCLK-

RCLK+

11

12

RC-

RC+

8

9

RB-

RB+

5

6

RA-

RA+

2

3

IC803

RGB AMP

2 41R DA

G DA6

B DA11

23

22

21

RIN

GIN

BIN

SDA

SCL

CLP

R OUT

Q801

BUFF

G OUT 38 BUFF

Q814

B OUT 33 BUFF

Q815

TP805

R

TP804

G

TP803

B

R

G

B

CN405

TO

B BOARD

E

CN810

1

3

5

6

7

3

2

PECL DRV

IC811

7 DQ

Q

42

IC812

CLKMCLK

MCLK

LVDS RECEIVER

RC55

IC805

26CLKOUTTP813

VD

TP814

HD

6 RC6

HSO

VSO

RC3 1

RD6 2

RC4 3

RA1 29

RA2 30

RA3 32

RA4 33

RA5

34

RA6

35

RB0

37

RB1

38

RD2

39

RD3

41

RB2

42

RB3

43

RB4

45

RB5

46

RD4

47

RD5

49

RB6

50

RC0

51

RC1

53

RC2

54

55

RD1

CLOCK24

IC806

D/A CONVERTER

R443

R342

R241

B923

B822

B721

B620

B519

B418

B317

B216

B110

9

8

7

6

5

4

3

48

47

46

45

44

G4

G2

G3

G5

G6

G7

G8

R5

R6

R7

R8

R9

34IOR

TP815

R DA

IOG 32

TP816

IOB 28

TP817

G DA

B DA

36VREF 8 4

REF

IC807

9 RA-RA-

RA+10 RA+

RB+

RB-

12

11

RB+

RB-

RC+

RC-

16

15

RC+

RC-

RCLK+

RCLK-

18

17

RCLK+

RCLK-

RD+

RD-

20

19

RD+

RD-

R DA

G DA

B DA

IC809

TG

I/O10 211 I/O28

I/O110

HSO

VSO

Y2/SCLK27

IN2/MODE30

ISPEN7

SDI/IN08

18 SDO/IN1

I/O17

32DNW

33

PB DIRI/O18

CLP

36I/O21HCK1

I/O20 35HCK2

1A

INVERTER

1 1Y 2

IC808

2A3

3A5

4A9

5A11

6A13

HCK1R

4HCK1G

6HCK1B

8

10

12

2Y

3Y

4Y

5Y

6YHCK2R

HCK2G

HCK2B

PCG1213 6A 6Y

10

1 1A 1Y

11

5

9

3

3Y3A

4A

5A

4Y

5Y

2A 2Y

IC810

INVERTER

2

6

8

4

PRG

HST

VST

ENB

VCK

I/O16

I/O26 43

31

VSTI/O2 11

ENBI/O24 41

VCK

I/O19 34HST

I/O11 9PCG

PRG

FRP

IC822(5/6)

IC822(1/6)

1 2I/O25 42

C(LCD DRIVE,RGB AMP,AUDIO AMP,12CH DAC,TIMING GENERATER)

PLD

H(KEY INPUT,LED)

7-7 7-7

A B C D E F G H

1

2

3

4

5

VPL-CS1

C, H BLOCK

POS-CON2

IC814

SWITCH

(SAME AS R PROCESS)

(SAME AS R PROCESS)

+12V

+15.5V

+12V REG

IC802

OI

O

IC801

+15V REG

+16.5V I

PB DIR

34

IC822(2/6)

TP810

(B)

CN812

2

23

4

3

8

SIG4

SIG3

SIG5

+15.5V

6

9

7

13

24

15

14

SIG6

RGT

SIG1

HST

COM

HCK2B

HCK1B

SIG2 5

LCD PANEL

IC817

VID1

Q808,809

B INV

B OUT

POS-CON1

SCEN

INV-CON

DLY-CON

SID-OUT

ENB

FRP

PRG

B LCD DRIVER

VID4

VID6

VID2

VID5

VID3

20

19

1

21

22

VST

VCK

PSIG

PCG

DWN

BUFF

MCLK

MCLK

B VCOM

DWN

ENB 18B-SID IN B-SID B-SID OUT

(G)

LCD PANEL

(R)

LCD PANELCOM

COM

CN811

23

8

+15.5VIC815

TP806

G INV

G LCD DRIVER

3

4

6

5

7

24

13

9

SIG5

SIG3

SIG6

SIG2

SIG1

HST

RGT

14

15

18

19

21

1

22

20

HCK1G

HCK2G

VCK

ENB

PCG

PSIG

DWN

VST

VID1

BUFF

G-SIDG-SID IN

Q804,805

POS-CON1

POS-CON2

SCEN

SID-OUT

DLY-CON

ENB

INV-CON

PRG

FRP

MCLK

G VCOM

DWN

MCLK

VID3

VID5

VID2

VID6

G-SID OUT

G OUT 2VID4 SIG4

Q806,807

R-SID IN38SID-OUT

R-SID OUT

BUFF

R-SID

DWN 22DWN

HCK1R

1PSIG

21PCG

20VST

19VCK

18ENB

15

14HCK2R

13

24

HST33VCOM OUT

RGT 913DIR-CNT

+15.5V

8

23

SIG1

SIG3

SIG5

SIG2

SIG6

SIG4

731SH-OUT1

VID117SH-OUT6

VID629SH-OUT2

VID219SH-OUT5

VID527SH-OUT3

VID3

VID4 2

4

5

3

6

CN813

VCOM OFST34R VCOM

MCLKMCLK50

MCLK51MCLK

ENB

FRP

PRG

12

44

62 PRG

FRP

ENB

52INV-CON

INV-CNT

49DLY-CON

DLY-CNT

39SID-OUT

SID-IN

35SCEN

SIG CEN

2POS-CON2

POS-CNT2

R INV

TP809

R OUTVIDEO IN

1POS-CON1

POS-CNT1

47

POS-CON2

INV-CON

DLY-CON

DWN

SCEN

POS-CON1

B VCON

G VCON

R VCON

4A05

SID-OUT

R LCD DRIVER

SH-OUT4 21

INV-OUT46

IC818

PRG15

1

2BUFF

Q803

Q802

BUFF

12A011

13A012

DALD

SDAT

D-SCLK

12CH D/A CONVERTER

IC813

3A04

A03 2

8

9

19

5

A09

A010

SH2

A06

A08 7

17

16

15

DI

CLK

LD

18

6

SCEN

A07

C, H C, H

7-8 7-8

A B C D E F G H

1

2

3

4

5

VPL-CS1

A

TO QA BOARD

CN101

POWER SUPPLY,DC-DC CONVERTER,

CN601

GA

3

1

AC

INLET

AC(N)

AC(L)

LFT

L601

1

4 3

2

D601

RECT

POWER-FACTOR

REGULATING CONTROL

OVP 4

VIN 6

5VFB

9

ON/OFF12

VC

10 VCC

16 IDET OUT 8

VDET3

SWITCHING

Q601IC605

7

6

5

9

8

1

3

2

4

SRT

T601

INV

Q604

RECT

D602

D610

RECT

NOIS

FILTER

NOIS

FILTER

D607

D608

PWM CONTROL

IC603

D C

S

RECT

D609

POWER

ON

Q603

4

3 2

1

PH601

ISOLATER

ISOLATER

PH602

1

23

4

1

CN607

IC602

SHUNT REG

1 K 8REF

A 7

G

OI

IC672

+5V REG

T602

SRT

2

5

3

12

11

IC604

PWM CONTROL

DC

S D621

RECT

6

10

9

+6V RECT

D615,617

4

3 2

1

PH603

ISOLATER

7A

REF 8K1

SHUNT REG

IC671

SW

Q671

CN602

1

CN608

1

CN605

1SUB+5V

GND 1 B

GND

DC W

SUB+5V 2

GND2 3

GND2 4

4GND2

3FAN PROT

2GND2

POWER CONT 1

CN604

6

518V

GND2

GND2

6V 5

6

CN606

1T-OUT12

T-OUT12 2

T-OUT11 3

6V 4

8

7

10

9

GND2

GND2

GND2

18V

GBA(FAN DRIVE,DC-DC CONVERTER)

CN671

5

6

1

2

3

4

GND2

18V

GND2

FAN PROT

GND2

POWER CONT

CN676

3

2

1 FAN +B

FAN PROT

GND2

FAN 1

FAN 2

GND2

FAN PROT

FAN +B1

2

3

CN675

2BST

VSW 8FB3

DC-DC CONVERTER

IC673

REG

IC704

I O

G

1 VIN

D672

FAN PROT

SW

Q672,673

ADJ

RECT

D673

3

2

1

5

4

GND2

FAN CONT2

FAN CONT1

FAN PROT

POWER CONT

CN674

CN807

TO C BOARD

C

9

10

7

8

4

3

2

1

6

5

CN702

(+16.5V REG,AUDIO +B REG)GBB

T-OUT12

T-OUT12

T-OUT11

6V

6V

GND2

GND2

GND2

GND2

18V

AUDIO

AMP

Q710D728

RECT

RECT

D715

O

G

I

IC701

+16.5V REG

CN706

5

6

1

3

4

2

D

TO C BOARD

CN802

7

8

8

7

2

4

3

1

6

5

CN707

9

CN102

TO QA BOARD

B

AUDIO+B

AUDIO+B

AUDIO GND

AUDIO GND

+16.5V

+16.5V

GND2

GND2

+16.5V

AUDIO+B

GND2

GND2

+6V

+6V

GND2

GND2

GND2

POWER-FACTOR REGULATING CONTROL

GA, GBA, GBB BLOCK

GA, GBA, GBB GA, GBA, GBB

8-1 8-1

A B C D E F G H

1

2

3

4

5

VPL-CS1

Section 8Diagrams

1 2 3 1 2 3 1 2 3 4 5 6 7 8

1 2 3 4 5 6 7 8 9 10

12345678910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

1 2 3 4 5 6 7 8 1 21 2 31 2 3 4 5 6 7 8 9 10

11

12 1 2 3 4 5 6 7 8

1 2 3 4 5

1 2 3 4

1 2 3

A1

B1

A2

B2

A3

B3

A4

B4

A5

B5

A6

B6

A7

B7

A8

B8

A9

B9

A10

B10

A11

B11

A12

B12

A13

B13

A14

B14

A15

B15

A16

B16

A17

B17

A18

B18

A19

B19

A20

B20

A21

B21

A22

B22

A23

B23

A24

B24

A25

B25

1 2 3 4 5

1 2 3 4 5

1 2 3 4

1 2 3 4 5 6 7 8 9

1 2 3 4 5 6 7 8 9 10

123

12345678910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

12345678910

11

12

13

14

15

16

17

18

19

20

21

22

23

2412345678910

11

12

13

14

15

16

17

18

19

20

21

22

23

24 123456789

1 2 3 4 5 6 7 8 9 10

11

12

1 2 3 4 5 6

1 2 3 4 5 6

CN674CN675 CN676

CN671

CN7106

CN7107

CN7102

CN604 CN606

CN601

CN803

CN810

CN811

CN813

CN812 CN805CN806CN808

CN807 CN802

CN809

CN804CN814

CN001

CN801

CN672

4PWHT

:S-MICRO3PWHT

:S-MICRO

3PBLK

:S-MICRO

8PWHT

8PWHT

:S-MICRO

9PRED

:S-MICRO10P

8P 10P

3P:VH-B

32PWHT

8PWHT:SMD

24PWHT

24PWHT

24PWHT

2PRED:SMD

3PWHT:SMD

12PWHT:SMD

4PWHT:SMD

8PWHT:SMD

5PWHT:SMD

9PWHT:SMD

4PRED:SMD

12P:SMD

50P

WHT

4P

GBA

GBB

GA

PLD

VISCA

M.OUT

C

H

LAMP

BALAST

FAN1FAN2

LCD

LCD

(R)

(B)

LCD (G)PANEL PANEL

PANEL

TEMP

FUSE

SPEAKER

AC IN

100V-120V

220V-240V

50/60Hz

GND 2

GND 2

T-OUT12

T-OUT11

GND 2

T-OUT12

GND 2

GND 2

POWER CONT

GND 2

18V

GND 2

FAN PROT

6V

6V

18V

AC(N)

AC(L)

TO AC INLET

N.C

GND

GND

SUB 5V

SUB 5V

TO QA BOARD CN101

GND 2

GND 2

GND 2

+6V

+6V

GND 2

GND 2

GND 2

GND 2

T-OUT11

T-OUT12

GND 2

T-OUT12

GND 2

GND 2

POWER CONT

GND 2

18V

GND 2

FAN PROT

6V

6V

16.5V

AUDIO+B

FAN PROT

FAN PROT

TO FAN2

TO FAN1

GND 2

GND 2

FAN+B

FAN+B

AUDIO+B

AUDIO+B

GND 2

GND 2

+16.5V

+16.5V

AUDIO GND

AUDIO GND

POWER CONT

FAN PROT

GND 2

FAN CONT2

FAN CONT1

18V

SCI

GND

FLAG

GND

GND

LIGHT

D.5V

PSAVE-LED

POWER-LED

TEMP-LED

LANP-LED

SUB 5V

KEY1

KEY0

SIRCS NR

A-G

A-L

GND

SDAT

GND

SCLK

GND

GND

GND

A+5V

A+5V

GND

D+5V

GND

D+3.3V

GND

SUB+5V

GND

RXD

A-G

A-L

GND

SDAT

GND

SCLK

GND

GND

A+5V

A+5V

GND

D+5V

GND

D+3.3V

GND

SUB+5V

GND

GND

TXD

EXT SW

FAN ON

LAMP ON

POWER ON

FAN CONT1

FAN PROT

LAMP SENS

AUDIO CS

DAC CS

AUDIO MUTE

A-R

L CONT IN

L CONT OUT

GND

AUDIO +B

AUDIO GND

+16.5V

GND

+16.5V

AUDIO GND

AUDIO +B

R

GND

G

GND

B

GND

HD

VD

5V

SP-R

SP-L

AUDIO GND

AUDIO GND

POWER CONT

FAN PROT

GND 2

FAN CONT2

FAN CONT1

GND

GND

N.C

KEY0

KEY1

SUB 5V

LAMP LED

POWER LED

D 5V

TEMP LED

PSAVE LED

N.C.

SCLK

GND

MODE

PLUG

SDI

SDO

VCC

ISPEN

SCI

GND

FLAG

GND

KEY1

GND

GND

GND

SDA

GND

GND

GND

RD-

GND

RCLK+

GND

GND

GND

RA+

RA-

GND

RC+

RC-

RB+

RB-

RCLK-

RD+

SCL

LCD TEMP

LAMP TEMP

KEY0

PSAVE LED

LAMP LED

TEMP LED

POWER LED

RXD

TXD

GND

EXT SW

SUB 5V

PSIG

HVDD

MODE3

MODE2

MODE1

HST

HCK2

VSS

BLK

ENB

VST

PCG

DWN

VVDD

COM

HCK1

VCK

SIG4

SIG3

SIG5

SIG2

SIG6

SIG1

XRGT

PSIG

HVDD

MODE3

MODE2

MODE1

HST

HCK2

VSS

BLK

ENB

VST

PCG

DWN

VVDD

COM

HCK1

VCK

SIG4

SIG3

SIG5

SIG2

SIG6

SIG1

RGT

PSIG

HVDD

SIG4

SIG3

SIG5

SIG2

SIG6

SIG1

BLK

ENB

VST

PCG

DWN

VVDD

COM

VCK

MODE3

MODE2

MODE1

HST

HCK2

VSS

HCK1

RGT

TO QA BOARD CN102

A-R

B-SS1697<08.>-KESSEN-P2

TO B BOARD CN405

TO B BOARD CN403

FRAME (1/2) FRAME (1/2)

8-1. Frame Schematic Diagram

8-2 8-2

A B C D E F G H

1

2

3

4

5

VPL-CS1

A1

A2

A3

A4

A5

A6

A7

A8

A9

A10

A11

A12

A13

A14

A15

A16

A17

A18

A19

A20

A21

A22

A23

A24

A25

A26

A27

A28

A29

A30

A31

A32

A33

A34

B1

B2

B3

B4

B5

B6

B7

B8

B9

B10

B11

B12

B13

B14

B15

B16

B17

B18

B19

B20

B21

B22

B23

B24

B25

B26

B27

B28

B29

B30

B31

B32

B33

B34

A35

B35

A1

A2

A3

A4

A5

A6

A7

A8

A9

A10

A11

A12

A13

A14

A15

A16

A17

A18

A19

A20

A21

A22

A23

A24

A25

A26

A27

A28

A29

A30

A31

A32

A33

A34

B1

B2

B3

B4

B5

B6

B7

B8

B9

B10

B11

B12

B13

B14

B15

B16

B17

B18

B19

B20

B21

B22

B23

B24

B25

B26

B27

B28

B29

B30

B31

B32

B33

B34

A35

B35

A1

A2

A3

A4

A5

A6

A7

A8

A9

A10

A11

A12

A13

A14

A15

A16

A17

A18

A19

A20

A21

A22

A23

A24

A25

A26

A27

A28

A29

A30

A31

A32

A33

A34

B1

B2

B3

B4

B5

B6

B7

B8

B9

B10

B11

B12

B13

B14

B15

B16

B17

B18

B19

B20

B21

B22

B23

B24

B25

B26

B27

B28

B29

B30

B31

B32

B33

B34

A35

B35

A1

A2

A3

A4

A5

A6

A7

A8

A9

A10

A11

A12

A13

A14

A15

A16

A17

A18

A19

A20

A21

A22

A23

A24

A25

A26

A27

A28

A29

A30

A31

A32

A33

A34

B1

B2

B3

B4

B5

B6

B7

B8

B9

B10

B11

B12

B13

B14

B15

B16

B17

B18

B19

B20

B21

B22

B23

B24

B25

B26

B27

B28

B29

B30

B31

B32

B33

B34

A35

B35

A1

B1

A2

B2

A3

B3

A4

B4

A5

B5

A6

B6

A7

B7

A8

B8

A9

B9

A10

B10

A11

B11

A12

B12

A13

B13

A14

B14

A15

B15

A16

B16

A17

B17

A18

B18

A19

B19

A20

B20

A21

B21

A22

B22

A23

B23

A24

B24

A25

B25

123

123456789 123

1 2 3 4 5 6 7 8 9 10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

1234

A1

B1

A2

B2

A3

B3

A4

B4

A5

B5

A6

B6

A7

B7

A8

B8

A9

B9

A10

B10

A11

B11

A12

B12

A13

B13

A14

B14

A15

B15

A16

B16

A17

B17

A18

B18

A19

B19

A20

B20

A21

B21

A22

B22

A23

B23

A24

B24

A25

B25

A1

B1

A2

B2

A3

B3

A4

B4

A5

B5

A6

B6

A7

B7

A8

B8

A9

B9

A10

B10

A11

B11

A12

B12

A13

B13

A14

B14

A15

B15

A16

B16

A17

B17

A18

B18

A19

B19

A20

B20

A21

B21

A22

B22

A23

B23

A24

B24

A25

B25

12345678

CN103

CN104

CN201

CN401

CN403

CN071

CN102

CN123

CN405

CN101

CN105

CN402

CN406

70P

70P

70P

70P

50P

3PRED:SMD

9P

3P:SMD

32P

WHT

4P

50P

50P

8PWHT:SMD

QA

BA

FLASH

B

NF

TO GBB BOARD CN7107

TO GA BOARD CN674

TO C BOARD CN801

GND

KEY1

GND

GND

GND

SDA

GND

GND

GND

GND

GND

GND

GND

GND

SCL

LAMP TEMP

KEY0

PSAVE LED

LAMP LED

TEMP LED

POWER LED

PANEL TEMP

A-G

A-L

GND

SDAT

GND

SCLK

GND

GND

GND

A+5V

A+5V

GND

D+5V

GND

D+3.3V

GND

SUB+5V

GND

RXD

A-G

A-L

GND

SDAT

GND

SCLK

GND

GND

A+5V

A+5V

GND

D+5V

GND

D+3.3V

GND

SUB+5V

GND

GND

TXD

EXT SW

FAN ON

LAMP ON

POWER ON

FAN CONT1

FAN PROT

LAMP SENS

AUDIO CS

DAC CS

AUDIO MUTE

A-R

TA-

TA+

TB-

TB+

TC-

TC+

TCLK-

TCLK+

TD-

TD+

TXD

RXD

VIN

GND

RES

FWR

MD1

MD2

A+5V

A+5V

GND

GND

A+3.3V

GND

D+5V

D+5V

GND

GND

D+3.3V

D+3.3V

GND

GND

SUB+5V

SUB+5V

GND

GND

SUB+3V

SUB+3V

GND

SDA

SCL

FAN-C

GND

GND

A-R

A-G

A-L

A+5V

A+5V

GND

GND

A+3.3V

GND

D+5V

D+5V

GND

GND

D+3.3V

D+3.3V

GND

GND

SUB+5V

SUB+5V

GND

GND

SUB+3V

SUB+3V

GND

SDA

SCL

LAMPC

GND

GND

A-R

A-G

A-L

GND

R-Y

GND

Y

GND

B-Y

GND

PALV

GND

15-CS

GND

GND

V-G

GND

V-B

GND

V-HD

V-VD

V-CLP

V-R

GND

R-Y

GND

Y

GND

B-Y

GND

PALV

GND

15-CS

GND

GND

V-G

GND

V-B

GND

V-HD

V-VD

V-CLP

V-R

F-CL

F-CL

F-DA

F-DA

F+5V

F+5V

U-DA

U-CL

SIRES

SIRES

GND

GND

NF OFF

NR OFF

FILC

+9V

+9V

GND

A5V

A5V

GND

SDA

GND

SCL

V-HD

V-VD

V-CLP

GND

C

GND

Y

GND

VIDEO

GND

V-B

GND

V-G

GND

V-R

GND

15K-CS

PAL-V

B-Y

Y

R-Y

+9V

+9V

GND

A5V

A5V

GND

SDA

GND

SCL

V-HD

V-VD

V-CLP

GND

C

GND

Y

GND

VIDEO

GND

V-B

GND

V-G

GND

V-R

GND

15K-CS

PAL-V

B-Y

Y

R-Y

GND

GND

F-CL

F+5V

F+5V

F-DA

F-DA

F-CL

S-IN

S-IN

GND

+6V

GND

GND

+6V

GND

GND

SUB+5V

GND

SIRCS-NF

GND

GND

SUB 5V

SUB 5V

+16.5V

AUDIO+B

SUB+5V

GND

SIRCS-NF

TO C BOARD CN803

A-R

Y

GND

VIDEO

GND

V-B

GND

V-G

GND

V-R

GND

B-Y

R-Y

GND

Y

GND

VIDEO

GND

V-B

GND

V-G

GND

V-R

GND

B-Y

R-Y

GND

GND

GND

V-HD

V-VD

V-CLP

GND

C

GND

15K-CS

PAL-V

Y

GND

V-HD

V-VD

V-CLP

GND

C

15K-CS

PAL-V

Y

S-IN

S-IN

+9V

+9V

GND

A5V

A5V

GND

SDA

SCL

+9V

+9V

GND

A5V

A5V

GND

SDA

SCL

F-CL

F+5V

F+5V

F-DA

F-DA

F-CL

GND

GND

GND

GND

GND

GND

GND

GND

PALV

15-CS

GND

GND

V-G

GND

V-B

GND

V-HD

V-VD

V-CLP

PALV

15-CS

GND

GND

V-G

GND

V-B

GND

V-HD

V-VD

V-CLP

GND

GND

GND

GND

GND

GND

GND

GND

GND

GND

GND

R-Y

GND

Y

GND

B-Y

GND

GND

V-R

GND

R-Y

GND

Y

GND

B-Y

GND

GND

V-R

GND

GND

A-R

A-G

A-L

GND

GND

A-R

A-G

A-L

U-DA

U-CL

SIRES

SIRES

NF OFF

NR OFF

SCL

SDA

SCL

LAMPC

F-CL

F-CL

F-DA

F-DA

F+5V

F+5V

A+5V

A+5V

GND

GND

A+3.3V

GND

D+5V

D+5V

GND

GND

D+3.3V

D+3.3V

GND

GND

SUB+5V

A+5V

A+5V

GND

GND

A+3.3V

GND

D+5V

D+5V

GND

GND

D+3.3V

D+3.3V

GND

GND

SUB+5V

SUB+5V

GND

GND

SUB+3V

SUB+3V

GND

SDA

SUB+5V

GND

GND

SUB+3V

SUB+3V

GND

B-SS1697<08.>-KESSEN-P1

FRAME (2/2) FRAME (2/2)

8-3 8-3

A B C D E F G H

1

2

3

4

5

VPL-CS1

8-2. Schematic Diagrams andPrinted Wiring Boards

Note:• Parts marked “ * ” differ according to the model/destination. Refer

to the mount table for each function.• The parts marked “ # ” on schematic diagrams are not mounted.• All capacitors are in µF unless otherwise noted. pF: µµF 50WV or

less are not indicated except for electrolytics.• All electrolytics are in 50 V unless otherwise specified.• : fusible resistor• : nonflammable resistor• : panel designation and adjustment for repair• Caution when replacing chip parts

New parts must be attached after removal of the chip.Be careful not to heat the minus side of a tantalum capacitor,because it is easily damaged by the heat.

Reference informationRESISTOR RN : METAL FILM

RC : SOLIDFPRD : NONFLAMMABLE CARBONFUSE : NONFLAMMABLE FUSIBLERS : NONFLAMMABLE METAL OXIDERB : NONFLAMMABLE CEMENTRW : NONFLAMMABLE WIREWOUND

: ADJUSTMENT RESISTOR

COIL LF-8L : MICRO INDUCTOR

CAPACITOR TA : TANTALUMPS : STYROLPP : POLYPROPYLENEPT : MYLARMPS : METALIZED POLYESTERMPP : METALIZED POLYPROPYLENEALB : BIPOLARALT : HIGH TEMPERATUREALR : HIGH RIPPLE

[Measuring conditions, voltage and waveform]• A voltage value is the reference value between the measurement

point and the earth, when the NTSC color bar signal is receivedfrom the color bar generator (digital multi-meter used: 10 M ohms/V DC).

• A voltage value is the reference value between the measurementpoint and the earth, when the NTSC color bar signal and RGBcolor bar signal are received from the color bar generator (digitalmulti-meter used: 10 M ohms/V DC).

• Unit of voltage is V (volt).• : B+line

: B– line• Voltage variations may occur due to normal production tolerances.• No mark : NTSC (3.58 MHz) color bar signal.• [ ] : RGB color bar signal is received.• : Measurement disabled.• Circled numbers indicate the reference waveform.• : Signal path.



8-4 8-4

A B C D E F G H

1

2

3

4

5

VPL-CS1

QA – B SIDE –SUFFIX ; -11

QA – A SIDE –SUFFIX ; -11

——QA——1-675-792-11

D101 E-2D102 E-2D103 F-3D104 F-3D105 C-7D106 C-7D107 C-6D108 C-6D109 D-5D121 ∗ D-4D122 ∗ D-4D123 ∗ D-3D124 ∗ F-5D125 ∗ F-5D126 ∗ F-5D127 ∗ E-5D128 ∗ E-5D129 ∗ F-6D130 ∗ F-6D131 ∗ F-6D133 ∗ D-2D135 ∗ D-3

IC101 E-4IC102 E-4IC103 D-3IC104 E-3IC105 D-4IC105 E-6IC107 D-5IC108 D-5IC121 E-7IC121 ∗ F-7IC122 E-3IC123 E-2IC124 ∗ E-1IC125 E-1IC127 C-1IC128 D-1

Q102 ∗ E-2Q103 ∗ E-2Q104 ∗ F-3Q105 ∗ E-1Q106 ∗ D-2Q107 ∗ D-2

TP101 C-1TP102 C-1

X101 E-4X102 D-1X103 E-1

*:B Side mount

7

6

5

4

3

2

1

ABCDEF A B C D E F

1

2

3

4

5

6

7

NF, QA NF, QA

NF – B SIDE –SUFFIX ; -11

NF – A SIDE –SUFFIX ; -11

8-5 8-5

A B C D E F G H

1

2

3

4

5

VPL-CS1

NF, QA (1/2) NF, QA (1/2)

+5V

+5V

+6V

+5V

+6V

VIDEO

C

Y

R

G

B

VIDEO

Y

Y

L

R

A1

A2

A3

A4

A5

A6

A7

A8

A9

A10

A11

A12

A13

A14

A15

A16

A17

A18

A19

A20

A21

A22

A23

A24

A25

A26

A27

A28

A29

A30

A31

A32

A33

A34

B1

B2

B3

B4

B5

B6

B7

B8

B9

B10

B11

B12

B13

B14

B15

B16

B17

B18

B19

B20

B21

B22

B23

B24

B25

B26

B27

B28

B29

B30

B31

B32

B33

B34

A35

B35

A1

A2

A3

A4

A5

A6

A7

A8

A9

A10

A11

A12

A13

A14

A15

A16

A17

A18

A19

A20

A21

A22

A23

A24

A25

A26

A27

A28

A29

A30

A31

A32

A33

A34

B1

B2

B3

B4

B5

B6

B7

B8

B9

B10

B11

B12

B13

B14

B15

B16

B17

B18

B19

B20

B21

B22

B23

B24

B25

B26

B27

B28

B29

B30

B31

B32

B33

B34

A35

B35

12

34 5

67

8

1

2

3

4

5

6

7

8

9

VCC

OUT

GND

12

34

1

2

3

G

I OG

I OG

1

2

3

4

12

34 5

67

8

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

1

2

3

12

34 5

67

8

EMI

EMI

EMI I OG

EMI

EMI

A1

B1

A2

B2

A3

B3

A4

B4

A5

B5

A6

B6

A7

B7

A8

B8

A9

B9

A10

B10

A11

B11

A12

B12

A13

B13

A14

B14

A15

B15

A16

B16

A17

B17

A18

B18

A19

B19

A20

B20

A21

B21

A22

B22

A23

B23

A24

B24

A25

B25

I OG

I OG

12

34 5

67

8

VCC

OUT

GND

J102

R101

R102

R103

R104

R105

R106

R107

C102

C103

C106 C107 C108C109

C111

C112

C116 C117

L102

L104

L105

L106

L107

JL101

JL102

JL104

JL105

JL106

JL107

JL108

JL109

JL110JL111

JL112

JL113

IC103

D103

D105

D106

FL101

FL103

FL104

FL105

CN103

L103

R118

C119

J101

FB121

FB129

FB130

C121

C122

C125C126

C127

D128

IC121

JL122

JL128

JL129

R121

R122

R123

R128

R130

R131

R133 R134

C130

C131

JL131

JL132

JL133

C132

JL115

JL116

C114

C115

CN123

R137

JL137

R139

JL118

CN102

C135

C110

FL102

D108

D107

C128

C129

C134

IC101IC102

IC104

IC106

Q102

Q103

Q104

R111

R112

R108 R113

R114

R109

R115

R116

R110

D101

D102

D104

C101

C120

R158

R159

R160

R138

D127

R140

R141

CN104

L109

CN101

R135

R136

R146

R161

R165

R166

R164

D109 R163

JL103

JL114

R147

R100

L101

JL121

C146

R117

C137

C133

R162

X101C164

C165

R198

C166

D123

D121

D135

C169

R127R119

L108

R120

C118

C136

JL134

JL135

C105

R143

R199

D122

JL141

JL142

JL143

C123

C113

L131

FB138

IC123

CN105

CN106

FB137

R167

CN122

CN071

C071

R071

R072

IC071

JL144

S101S202

JL140

IC107

IC122

IC105

C104

IC10847

6.3V

:AL-CP

2216V

:AL-CP

2216V

:AL-CP

476.3V:AL-CP

2216V

:AL-CP

#

#

#

NFM41P11C204

NFM41P11C204

4716V

:AL-CP

#

#

NFM41P11C204

#

#

NFM41P11C204

470k:CHIP

470k:CHIP

BLm21B03

BLm21B03#

#

476.3V:AL-CP

2216V

:AL-CP

0.125V

B:CHIP

75:RN-CP

75:RN-CP

75:RN-CP

RD5.6SB-T1PROTECT

BLm21B03

BLm21B03

BLm21B03

47

16V

:AL-CP

4716V

:AL-CP

100:CHIP

#

#

100

16V

:AL-CP

0.125V

B:CHIP

47

:CHIP

47:CHIP

5.6k

:CHIP

5.6k

:CHIP

56k:CHIP

56k

:CHIP

#

#

#

BLm21B03

47

6.3V

:AL-CP

47

6.3V

:AL-CP

#

#

#

47

6.3V

:AL-CP

#

#

#

#

0.0033B:CHIP

0.125V

B:CHIP

100pCH:CHIP

100pCH:CHIP

70P

3P:SMD

BK2125HM601

BK2125HM601

BK2125HM601

TA78M09F(TE16L)9V REG

GP1U28Y

#

0:CHIP

1.8k:RN-CP

100:CHIP

100:CHIP

100:CHIP

1

10V

B:CHIP

3325V

:AL-CP

9P

NFM41P11C204

47

6.3V

:AL-CP

47

6.3V

:AL-CP

47

6.3V

:AL-CP

10010V

:TA-CP

D1FS4A-TA

BA033FP-E23.3V REG

BA033FP-E23.3V REG

PQ05AZ1U5V REG

PQ05AZ1U5V REG

D1FS4A-TA

RD5.6SB-T1PROTECT

RD5.6SB-T1PROTECT

RD5.6SB-T1PROTECT

110V

B:CHIP

22k:CHIP

22k:CHIP

22k:CHIP

22k:CHIP

22k:CHIP

22k:CHIP

1016V

:AL-CP

100:CHIP

100:CHIP

100:CHIP

2SC2712

2SC2712

2SC2712

1k:CHIP

1k:CHIP

1k:CHIP

47k

:CHIP

100

:CHIP

47k

:CHIP

70P

10k

:CHIP

10k

:CHIP

10k

:CHIP

1k

:CHIP

47k

:CHIP

56k

:CHIP

33k

:CHIP

1SS355 100k

:CHIP

#

#

4.7k

:CHIP

4P

4.7µH

4.7k:RN-CP

#

0.1

25V

B:CHIP

5.6k

:CHIP

100p

CH:CHIP

BLm41P750S

100p

CH:CHIP

100k

:CHIP

1.5k

:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

1M

:CHIP

56k

:CHIP

33pCH:CHIP

33pCH:CHIP

RD9.1SB2-T1PROTECT

RD9.1SB2-T1PROTECT

RB501V

RB501V

RD5.6SB-T1

RD5.6SB-T1

RB501V

75:RN-CP

5.6k:CHIP

2210V

F:CHIP

1010V

F:CHIP

10µH

24MHz

#

#

10k

:CHIP

10k

:CHIP

RD5.6SB-T1PPOTECT

1020V

:TA-CP

#

#

#

22

10V

F:CHIP

826.3V:AL-CP

0

0:CHIP

50P

4P

0:CHIP

27k

:CHIP

PIC12C509 REMOTE SW

6PBUS

3PWHT:SMD

1020V

:TA-CP

471/10W:CHIP

1001/10W:CHIP

RS-140-TIR-RX

#

#

TA75W393FUPROFECTOR

RCV4-A1S-OTPRCV4

LT1376IS#TR3.3V DDC

10 20V :TA-CP

TA75W393FUPROFECTOR

CLK

DAT/RI

+5V/DTR

+6V

AUDIO +B

+16.5V

9V

C-V

S-Y

S-C

A-L

A-R

5V-2

3.3V-2

3.3V-3

5V-3

6V

5V-2

5V-3

A-L

A-R

A-GND

S-C

S-Y

C-V

3.3V-3

5V-3

5V-3

A-GND

U-DA

U-CL

3.3V

9V

3.3V-2

SIRCS

S SEL

SIRCS

S SEL

5V

5V

5V

3.3V

16.5V

SUB 5V

NF ON

NR ON

NF ON

NR ON

USB5V

DS2-

DS2+

USB REG

SDA

V-HD

V-VD

V-CLP

V-B

V-G

V-R

15K-CS

PAL-V

R-Y

Y

B-Y

B-Y

Y

R-Y

V-G

V-R

V-CLP

V-VD

V-HD

V-B

PAL-V

SDA

SCL

F+5V

F-DA

F-CL

F-CL

F+5V

F-DA

15K-CS

SCL

A+5V

A+5V

GND

GND

A+3.3V

GND

D+5V

D+5V

GND

GND

D+3.3V

D+3.3V

GND

GND

SUB+5V

SUB+5V

GND

GND

SUB+3V

SUB+3V

GND

SDA

SCL

FAN-C

GND

GND

A-R

A-G

A-L

A+5V

A+5V

GND

GND

A+3.3V

GND

D+5V

D+5V

GND

GND

D+3.3V

D+3.3V

GND

GND

SUB+5V

SUB+5V

GND

GND

SUB+3V

SUB+3V

GND

SDA

SCL

LAMPC

GND

GND

A-R

A-G

A-L

+9V

+9V

GND

A5V

A5V

GND

SDA

GND

SCL

V-HD

V-VD

V-CLP

GND

C

GND

Y

GND

VIDEO

GND

V-B

GND

V-G

GND

V-R

GND

15K-CS

PAL-V

B-Y

Y

R-Y

+9V

+9V

GND

A5V

A5V

GND

SDA

GND

SCL

V-HD

V-VD

V-CLP

GND

C

GND

Y

GND

VIDEO

GND

V-B

GND

V-G

GND

V-R

GND

15K-CS

PAL-V

B-Y

Y

R-Y

GND

R-Y

GND

Y

GND

B-Y

GND

PALV

GND

15-CS

GND

GND

V-G

GND

V-B

GND

V-HD

V-VD

V-CLP

V-R

GND

R-Y

GND

Y

GND

B-Y

GND

PALV

GND

15-CS

GND

GND

V-G

GND

V-B

GND

V-HD

V-VD

V-CLP

V-RA +5V

D +5V

GND

A +9V

SUB +3.3V

Vc

FB/SNS

BOOST

VIN

VSW

SHDN SYNC

GND

GND

SUB +5V

SUB +5V

GND

+6V

GND

GND

+6V

GND

GND

AUDIO IN

D +3.3V

A +3.3V

S

VIDEO

C Y

MOUSE

GND

GND

F+5V

F+5V

F-CL

F-CL

F-DA

F-DA

F+5V

F+5V

U-DA

U-CL

SIRES

SUB+5V

GND

GND

GND

GND

GND

GND

GND

GND

GND

GND

F-CL

F-DA

F-CL

F-DA

S-IN

S-IN

SIRCS-NF

SUB

SUB

SUB

SUB

+16.5V

AUDIO +B

PWR PROT

VDD

IRIN1

IRIN2

VSS

IROUTRES

IREN1

IREN2

NR

NF ON

ON

VDD

VSS

PC2

PC1

PC0

N.C.

PB7

PB6

PB5

PB4

PB3

PB2

PB1

VPP

VDDA

USBVCC

VSSA

PA0

PA1

N.C.

N.C.

N.C.

PA2

PA3

PA4

PA5

PA6

PA7

PB0

RESET

X2

X1

USB+

USB REG

USB-

TO B BOARD CN401

TO B BOARD CN402

TO (1/2)

TO (1/2)

TO (1/2)

TO (1/2)

TO BA BOARD CN201

LAMPCOVER

FILTERCOVER

TO (2/2)

TO (1/2)

TO (2/2)

TO (1/2)

TO (1/2)

TO (2/2)

TO (2/2) TO (1/2)

FROM (2/2)

TO (1/2)

TO GBB BOARD CN707

TO GA BOARD CN605

TO (1/2)

TO (1/2)

SUB+5V

GND

SIRCS-NF

TO NF CN071TO QA BOARD CN123

B-SS1697<08.>-NF.

(FRONT)

SIRCS RECEIVENF

B-SS1697<08.>-QA.-P1

(VIDEO INPUT,MOUSE CONNECTOR)

QA(1/2)

• Refer to page 8-4 for Printed Wiring Board

8-6 8-6

A B C D E F G H

1

2

3

4

5

VPL-CS1

QA (2/2) QA (2/2)

• Refer to page 8-4 for Printed Wiring Board

+5V

+3.3V

12

34

12 3

4

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

12

34 5

67

8

FB124

FB123

D124

D126

R125R124

D125

JL123

JL124

JL125

FB128

FB132

JL127

JL130

R151

R150

C141

C142

R154 R155

C138

D131

C143

C144

C139C140

R156

IC124

R157

FB136

R168

R170

R171

R172

R173

R174

R175

R176

R177

R149

R148

R182

R183

R142

R145

C148

C149

C150

C151

C152

C153

C154

R184

R185

R186 R187

C155C156

C157

C158

C159

C160

C161

R188

C162

FB139 D133

D129 D130

R195

TP101

TP102

R197

R193

R181R180R179R178

R169

R152

R153

X103

X102

C163

R129

R144

D136

R196R189

R194

FB134

FB126

J121

R126

FB125

FB127

FB131

J122

FB122

R192

JL117

FB133

IC125

IC128

Q105

Q107

Q106IC127

BK2125HM601

BK2125HM601

UDZ-TE-17-3.9B

15k:CHIP15k

:CHIP

UDZ-TE-17-3.9B

#

#

#

BK2125HM601

BK2125HM601

#

#

0.1

25V

B:CHIP

110V

B:CHIP

1006.3V:AL-CP

0:CHIP

0:CHIP

33k:CHIP

10k:CHIP

0.1

25V

B:CHIP

0.01

B:CHIP

100:CHIP

0.01B:CHIP

0.125V

B:CHIP

DAN202K

100

:CHIP

S-80842ANNPRESET

10k

:CHIP

15k :CHIP

15k :CHIP

15k :CHIP

15k :CHIP

510k

:CHIP

510k

:CHIP

0.1

25V

B:CHIP

10p

CH:CHIP

10p

CH:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

100k

:CHIP

100k

:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

0.01

B:CHIP

33p

CH:CHIP

33p

CH:CHIP

0.1

25V

B:CHIP

#

UDZ-TE-17-3.9B UDZ-TE-17-3.9B

10k

:CHIP

15 :CHIP

15 :CHIP

15 :CHIP

15 :CHIP

15:CHIP

15:CHIP

15:CHIP

15:CHIP

2.2k:CHIP

1.5k

:CHIP

226.3V:AL-CP

RD5.6SB-T1

RB501V

3k :CHIP

3k :CHIP

15

:CHIP

15

:CHIP15

:CHIP15

:CHIP

#

1.5k

:CHIP

1M

:CHIP

22

6.3V

:AL-CP

BLMP750S

BLMP750S

4MHz

24MHz

1k

:CHIP

100

:CHIP

#

#

100

:CHIP

0:CHIP

0:CHIP

0:CHIP

#

FBMH3216HM501NT

FBMH3216HM501NT

FBMH3216HM501NT

FBMH3216HM501NT

10k

:CHIP

#

0

:CHIP

ST72T631L4M1USB PJ CTRL

µPD16875G-E2USB POWER SUP

DTC144EKASW

2SA1162SW

DTC144EKASW µPD72012GB-003-

USB HUB CTRL

5V

USB5V

5V

RESET

RESET

DS2+

DS2-

3.3V

U-DA

U-CL

USB REG

3.3V

US+

US-

DS1+

DS1-

DS2+

DS2-

DS3+

DS3-

US+

US-

VBUS

DS3-

DS3+

DS2+

DS2-

VBUS

DS1+

DS1-

OUT

VDD

VSS

N.C.

CTL2

FLG2

FLG1

CTL1

OUT2

IN

GND

OUT1

VDD

OSCOUT

OSCIN

VSS

PC2

PC1

PC0

N.C.

PB7

PB6

PB5

PB4

PB3

PB2

PB1

VPP

VDDA

USBVCC

USBDM

USBDP

VSSA

PA0

PA1

N.C.

N.C.

N.C.

PA2

PA3

PA4

PA5

PA6

PA7

PB0

RESET

US+

US-

-1

-1

-1

A TYPE USB

TO (1/2)TO (1/2)

TO (1/2)

TO (1/2)

B TYPE USB

3B4

DVDD

DGND

PSSEL

PVSEL

DGND

RESET

UD1

UD0

D10

D11

DGND

D20

D21

D30

D31

DGND

DGND

D40

D41

D50

D51

DGND

CS2

CS1

DGND

DVDD

AVDD2

AGND2

AGND1

X1

CLK/X2

AVDD1

OSL

PP5

PP4

PP3

PP2

PP1

DVDD

DVDD

CLKSEL

CS5

CS4

CS3

(A/B USB CONNECTOR)

B-SS1697<08.>-QA.-P2

QA(2/2)

S-80842ANNP (IC124)

VOO 2

VSS 4

OUT1

VREF

8-7 8-7

A B C D E F G H

1

2

3

4

5

VPL-CS1

BA BA

D C B A

1

2

3

A B C D

1

2

3

——BA——1-675-793-11

IC201 B-3IC202 C-2IC221 A-3IC271 D-2IC301 B-1IC302 ∗ C-2

Q221 B-2Q222 A-2Q226 A-1Q227 ∗ A-1Q228 ∗ A-1Q229 ∗ A-1Q271 C-2Q272 D-2Q273 D-2Q302 ∗ B-2Q303 ∗ C-2

TP271 D-2TP272 D-2TP273 D-2TP274 C-1

X301 B-1

*:B Side mount

BA – B SIDE –SUFFIX ; -11

BA – A SIDE –SUFFIX ; -11

CXA1839Q (IC271)

3 6 9 12

15

18

2 5 8 11

14

17

1 4 7 10

34 31 28 2535 32 29 2636 33 30 27

13

16

21

22

20

24

23

19

46

43

47

44

48

45

40

39

41

37

38

42

Amp Clamp

Amp Clamp

YS2 YM2

Hue Color

Matrix Clamp

Pulse InterfaceCEC Axis

D-Color Bright

ABL Amp

Picture Clamp

YS1 YM1

Bus Dec

RGB

R G B

IREF

R-YG-YB-Y

R-YB-Y

YUV-SW VM Amp Sharpness

NR Clamp

D- Picture

Y

Y

B-Y R-Y

BY2-IN

RY2-IN

Y2-IN

NC

1REF

C-OFF

GND

ROUT

GOUT

BOUT

ABL-REQ

ABL-MUTE

AP-MUTE

CLP1

BGP

CBLK

FFTIM

VS

VEQ

VBLK

VTIM

SSCP

SCL

SDA

Y1-I

N

GN

D

RY1

-IN

BY1-

IN

GN

D1

VCC1

YUV-

SW

VM-M

UTE

SP-M

UTE

VM-O

UT

CLP-

C

APED

-C

LR2-

IN

LG2-

IN

LB2-

IN

YS2

YM2

VCC2

GN

D2

LR1-

IN

LG1-

IN

LB1-

IN

YS1

YM1

CXD2064Q-T6 (IC221)

2

1

9

42

CPO VCV PLSL FIN CKSL

44 39 37 38

ADIN

AYO

7 ACO

CLPO

A/D

VCO 1/4

1/2

DL D/A

D/A

NTSC:1H PAL :2H

NTSC:1H PAL :2H

CLAMP

+

-

+

-

SW

SW

4fsc

VERTICAL BORDER EMPHA

ADAPTIVE FILTER OP

LOGICAL OPERATION

PHASE COMPARATOR

CXA1875AM-T4 (IC201)

LATCH

DAC

AMP

LATCH

DAC

AMP

LATCH

DAC

AMP

LATCH

DAC

AMP

LATCH

DAC

AMP

+–

VCCREG

I2C DECODER

LEVEL CONVERTER

LEVEL CONVERTER

LEVEL CONVERTERLATCH

POWER ON

RESET

OPEN COLLECTOR

3 62 5 81 4 7

SW1

SW0

DAC

4

DAC

3

DAC

2

DAC

1

DAC

0

GN

D

14 1115 12 916 13 10

VCC

SCL

SDA

SAD

2

SAD

1

SAD

0

SW3

SW2

BA Board Waveforms

1 2 3

0.6 Vp-p TP271 [V-R]

0.6 Vp-p TP272 [V-G]

0.6 Vp-p TP273 [V-B]

8-8 8-8

A B C D E F G H

1

2

3

4

5

VPL-CS1

BA BA• Refer to page 8-7 for Printed Wiring Board• Refer to page 8-7 for Waveforms• Refer to page 8-7 for IC Block Diagrams

0

0 0 0

2.3

2.3

1.7

2.9

+5V

1.8

1.2

1.81.2

1.5

0.8

0.1

1.4

+5V

+5V

4.85.0

2.9

0.1

+9V

+9V

1 2 3

+5V

5.0

5.0

0.1

0.3

0.1

0.1

4.9

4.9

2.4

0.3

0.3

0.4

0.4

+5V

00

0.5

2.6

00

0.5

2.600

0.5

2.6

5.0

5.0

Y/R-Y/B-Y

B-Y

R-Y

Y

VIDEO

C

Y

R

G

B

1 2 3 4 6

791012

5

136

7 10

245

9 12

136

7 10

245

9 12

1 2 3 4 5 6 7 8 9 10 11 12 13 14

15

16

17

18

19

20

21

22

23

24

2526272829303132333435363738

39

40

41

42

43

44

45

46

47

48

1 2 3 4 5 6 7 8

910111213141516

EMIA1

A2

A3

A4

A5

A6

A7

A8

A9

A10

A11

A12

A13

A14

A15

A16

A17

A18

A19

A20

A21

A22

A23

A24

A25

A26

A27

A28

A29

A30

A31

A32

A33

A34

B1

B2

B3

B4

B5

B6

B7

B8

B9

B10

B11

B12

B13

B14

B15

B16

B17

B18

B19

B20

B21

B22

B23

B24

B25

B26

B27

B28

B29

B30

B31

B32

B33

B34

A35

B35

12

34 5

67

8

EMI

EMI

123456789101112

13

14

15

16

17

18

19

20

21

22

23

24

25 26 27 28 29 30 31 32 33 34 35 36

37

38

39

40

41

42

43

44

45

46

47

48

1 2 3 4 5 6 7 8 9 10 11 12

13

14

15

16

17

18

19

20

21

22

23

24

252627282930313233343536

37

38

39

40

41

42

43

44

45

46

47

48

12

3 45

Q221

R231

R225

R235

R243

FL221

Q229

Q227

R242

FL222

FL223

C221

C227

C226

C232

C238

C235

R252

C239

C234C233

C237

C241

C245

C246

R254 R255

C236

R248

C230

R285

R284

R274

R283

R294

R287

R286

R279

R278

R273

R293

R281

R275

R288 R298 R290

R277

R282

R292

IC201

R215

R214

R211

R212

R213

R210

R209

R314

Q302

C327C328

FL301

C303

JL201

JL202

JL203

JL204

JL205

JL206

JL207

JL208

JL209

JL210

JL211

JL212

JL213

JL214

JL215

JL216

JL218

JL219

JL220

JL221JL222

JL302

JL301

JL303

C300

R289

R299

R318

R320

JL223

FL302

FL303

R234

C222

C228

R230

IC221

R249

R250

R257R256

R258 R259

R261

R260

C242

C240

C243

C244

R240

R236

R239

R245

R237

IC271

C293C292

C291

C297

C276C277C278

C275

C282

C283

C284

C294

C295

C280

TP271 TP272 TP273

TP274

R271

C279

C281

FB271

C273

C271

R203R204

C201

R205

R206

R207

R208

R202

C331

C333

C332

C334

C317

R310

C324

C325

C313

C315

R304

R303

C314

C202

R312

R313

C330R321

R305

C302C301

C312

FB201

R306

R316

Q222

Q226

Q228

C323

IC202

R253

R251

R222

C321

C322

C337

R276

R280 R291

R272

R300

R297

R311

L224

C274

L223

Q271

Q272

Q273

C285

C286

C287

R217

R218

C318

R309

R317 R324

C304 IC302

R216

R296

Q303

R322

R315

R323

R319

R244

R247

C319

C320

C296

JL224

JL225

JL226

JL227

JL228

JL229

C247

C326

R223

R227

FB202

C225

C224

L225

L226

L221

C338

R201

IC301

X301

R302

R228

L222

CN201

L271

2SC2712BUFF

1.2k:CHIP

560:CHIP

560:CHIP

560:CHIP

2SC2712BUFF

2SC2712BUFF

5.6k:CHIP

10016V

:AL-CP

10016V

:AL-CP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

3.3k:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

56k:CHIP

560:CHIP

10016V

:AL-CP

#

0.125V

B:CHIP

100:CHIP

100:CHIP

27k:CHIP

10k:CHIP

1k:CHIP

1k:RN-CP

1k:RN-CP

1.5k:RN-CP

680:RN-CP

1.5k:RN-CP

0:CHIP

0:CHIP

0:CHIP

100:CHIP

100

:CHIP

100:CHIP

33k:CHIP

33k:CHIP

33k:CHIP

100:CHIP

100:CHIP

10k:CHIP

10k:CHIP

100:CHIP

100:CHIP

100:CHIP

1k:CHIP

2SC2712

0.1

25V

B:CHIP

110V

B:CHIP

10p

CH:CHIP

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

##

#

#

#

110V

B:CHIP

100:CHIP

100

:CHIP

47:CHIP

47:CHIP

#

5.6k:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

33k

:CHIP

CXD2064Q-T6D.COMB

150

:RN-CP

150

:RN-CP

#0:CHIP

0

:CHIP

0

:CHIP#

#

0.125V

B:CHIP

0.125V

B:CHIP

0.022B:CHIP

0.001B:CHIP

#

0:CHIP

1k:CHIP

1k:CHIP

1k:CHIP

CXA1839Q-T6RGB DECODER

0.01B:CHIP

0.01B:CHIP

0.01B:CHIP

0.125V

B:CHIP

0.01B:CHIP

0.01B:CHIP

0.01B:CHIP

0.125V

B:CHIP

0.01B:CHIP

0.01B:CHIP

0.01B:CHIP

0.01B:CHIP

0.01B:CHIP

10

16V

:AL-CP

100:CHIP

116V

B:CHIP

110V

B:CHIP BK2125HM102

#

#

100:CHIP

100:CHIP

0.125V

B:CHIP

100:CHIP

100:CHIP

100:CHIP

100:CHIP

10k:CHIP

4716V

:AL-CP

4716V

:AL-CP

0.01B:CHIP

0.01B:CHIP

0.01 B:CHIP

0.01 B:CHIP

0.01

B:CHIP

0.01

B:CHIP

3.9k :CHIP

0 :CHIP

0.47

16V

B:CHIP

4716V

:AL-CP

100

:CHIP

100

:CHIP

0.01B:CHIP

100

:CHIP

100

:CHIP

0.1

25V

B:CHIP

4716V

:AL-CP

1016V

:AL-CP

BK2125HM102

330

:CHIP

3.3k

:CHIP

2SA1162BUFF

2SA1162

2SA1162

0.01B:CHIP

2.26.3VB:CHIP

0.022 B:CHIP

NFM41P11C204

NFM41P11C204

NFM41P11C204

27k:RN-CP

M24C64WMN6T

2.2k

:CHIP

1.5k

:CHIP

22k

:CHIP

0.1 25V B:CHIP

0.1 25V B:CHIP

0.01

B:CHIP

22k

:CHIP 22k

:CHIP22k

:CHIP

220

:RN-CP

100

:CHIP

#

4.7k:RN-CP

0.01

B:CHIP

0.01

B:CHIP

0.01

B:CHIP

10k

:CHIP

10k

:CHIP

4716V

:TA-CP

4.7µH

4.7µH

HN1B01FU-TE85RBUFF

HN1B01FU-TE85RBUFF

HN1B01FU-TE85RBUFF

4.735V

:AL-CP

3.3k

:RN-CP

6.8k

:CHIP47

:CHIP

0.1

25V

B:CHIP

TC75S56F

10k :CHIP

220:CHIP

2SC2712

0

:CHIP

1k

:CHIP

#

47

:CHIP

100:CHIP

560:CHIP

0.1 25V B:CHIP

0.1

25V

B:CHIP

0.01

B:CHIP

#

#

#

#

#

#

1

10V

B:CHIP

4.7k

:CHIP

1k

:CHIP

0.1 25V B:CHIP

4.7k

:CHIP

1020V

:TA-CP

2210V

:TA-CP

BK2125HS102

4.7µH:CHIP

4.7µH

4.7µH

826.3V

CXA1875AM-T4DAC

CXA2123AQ-T6COLOR DECODER

16.2MHz

0

:CHIP

1k

:CHIP

OµH

70P

OµH

:CHIP

COMB C

INPUTA/VIDEO

COMB Y

INPUTA/VIDEO

5V

5V

5V

5V

5V

5V

5V

9V

9V

5V

VEH1

VEH2

VEH3

NTPL1

VB-Y

VR-Y

VY

VEH3

VEH2

VEH1

NTPL1

VR-Y

VB-Y

VY

SCL

SDA

SDA

SCL

PALV

S-C

S-Y

VIDEO

V-CLP

V-HD

V-VD

V-B

V-G

V-R

Y

R-Y

B-Y

S-C

S-Y

VIDEO

15K-CS

PALV

SDA

SCL

SDA

SCL

V-CLP

V-VD

V-HD

R-Y

Y

B-Y

V-R

V-B

V-G

15K-CS

VRF

VG

DAVS

AYO

DAVD

ACO

RT

ADVD

ADVS

RB

ADIN

CLPO

DTR

PNR

VEH1

VEH2

VEH3

MOD1

DVSS

MOD2

DVDD

TEST

VB

IRF

NTPL2

NTPL1

DVDD

TEST

DVSS

APCN

TRAP

TEST

TEST

DVDD

TEST

DVSS

FIN

CKSL

PLSL

MCKO

ADCK

CPO

PLVS

VCV

PLVD

CLVD

CLPEN

CLVS

LG2-IN

LB2-IN

YS2

YM2

VCC2

GND2

LR1-IN

LG1-IN

LB1-IN

YS1

YM1

SDA

SCL

SSCP

V-TIM

VBLK

VEQ

VS

FFTIM

CBLK

BGP

CLP1

AP-MUTE

CLP-C

VM-OUT

SP-MUTE

VM-MUTE

YUV-SW

VCC1

GND1

BY1-IN

RY1-IN

Y1-IN

NC

BY2-IN

RY2-IN

Y2-IN

NC

IREF

C-OFF

R-OUT

G-OUT

B-OUT

ABL-REQ

ABL-MUTE

LR2-IN

APED-C

V-R V-G V-B

GND

GND

C3

APC-Fil

CVBS/Y3

C2

CVBS/Y2

COMB SYS

SFC OUT

AFC.Fi

C1

CVBS/Y1

SYNC IN

CVBS OUT(2VPpp)

VS

COMB Y

COMB C/FORCED S

D-GND

HS

SCP

Y FOR SYNC

SYNC-Vcc

SYNC-GND

Cr1

Cb1

Y1

Y OUT

Cb out

Cr out

YS1

B1

G1

R1

Y/C GND

Cr2

Cb2

Y2

Y/C Vcc

B2

G2

BPH-Fil

Xtal

D-VDD

SCL

SDA

YS3

APL FIL

R2

YS/YM

+9V

+9V

GND

A5V

A5V

GND

SDA

GND

SCL

V-HD

V-VD

V-CLP

GND

C

GND

Y

GND

VIDEO

GND

V-B

GND

V-G

GND

V-R

GND

15K-CS

PAL-V

B-Y

Y

R-Y

+9V

+9V

GND

A5V

A5V

GND

SDA

GND

SCL

V-HD

V-VD

V-CLP

GND

C

GND

Y

GND

VIDEO

GND

V-B

GND

V-G

GND

V-R

GND

15K-CS

PAL-V

B-Y

Y

R-Y

GND

GND

F-CL

F+5V

F+5V

F-DA

F-DA

F-CL

S-IN

S-IN

ADD(8EH)

TO QA BOARD CN104

B-SS1697<08.>-BA.

BACOLOR,DECORDERR,G,B,DECORDERD.COMB

VCC

SCL

SDA

SDA2

SDA1

SDA0

SW3

SW2

SW1

SW0

DAC4

DAC3

DAC2

DAC1

DAC0

GND

SCL

SDA

E0

E1

E2

GND

VCC

WC

8-9 8-9

A B C D E F G H

1

2

3

4

5

VPL-CS1

B B

1

2

3

G F E D C B A

1

2

3

A B C D E F G

—B—1-675-794-11

D401 A-2D402 A-2D403 A-2D404 ∗ A-2D406 ∗ A-2D408 ∗ G-2D409 ∗ F-2D410 ∗ B-2D411 ∗ B-3D412 ∗ B-3D413 ∗ A-2D414 ∗ A-2D415 ∗ C-3

IC401 ∗ B-2IC402 ∗ B-1IC403 B-2IC404 A-1IC405 ∗ B-2IC406 ∗ B-1IC407 D-2IC407 ∗ A-1IC408 C-1IC408 ∗ D-1IC410 B-1IC411 ∗ D-1IC412 ∗ C-2IC413 E-1IC414 ∗ E-1IC415 ∗ E-3IC416 ∗ C-2IC418 G-2IC419 ∗ F-3IC420 ∗ F-3IC421 ∗ E-3IC422 G-3IC423 ∗ E-2IC424 F-2IC425 ∗ E-2IC427 ∗ F-2IC428 E-2IC428 ∗ D-1IC429 ∗ C-3IC430 B-2

Q401 ∗ A-1Q402 ∗ A-1Q403 ∗ G-3Q405 ∗ B-3

TP401 ∗ B-2TP402 ∗ A-1TP403 ∗ A-1TP404 ∗ A-1TP405 ∗ B-2TP406 ∗ C-1TP407 ∗ G-1

X401 ∗ E-2X402 ∗ E-3X403 ∗ G-2

*:B Side mount

B Board Waveforms

1 2

3 4

5 6

0.6 Vp-p TP404 [R]

0.6 Vp-p TP403 [G]

3.6 Vp-p TP406 [PICLK]

0.6 Vp-p TP402 [B]

3.2 Vp-p TP405 [HSI]

3.2 Vp-p TP401 [VSI]

74VHC240MTCX (IC402)

20 19 18 17 16 15 14 13 12 11

1 2 3 4 5 6 7 8 9 10

Vcc

1Y1

2A4

1Y2

2A3

1Y3

2A3

1Y4

2A4

1A1

2Y4

1A2

2Y3

1A3

2Y2

1A4

2Y1

GN

D1G

2G

S-80842ANNP (IC419)S-80828ANNP (IC420)

VOO 2

VSS 4

OUT1

VREF

SN74CBTD3306PWR (IC410)

10E 1 8 VCC

1A 21B 3

GND 4 6 2B5 2A

7 2OE

TC74LCX04FT (IC421)

14 13 12 11 10 9 8

1 2 3 4 5 6 7

VCC

GND

B – B SIDE –SUFFIX ; -11

B – A SIDE –SUFFIX ; -11

8-10 8-10

A B C D E F G H

1

2

3

4

5

VPL-CS1

B (1/4) B (1/4)

0

0

+3.3V

4.6

5

0

0 03.3

3.2

3.2

0

0

0

0

0

0

3.2

3.2

3.2

3.2

0.2

0.8

2.9

0.8

0.3

2.9

4.6

3

2

1

+3.3V

+5V

4

+5V

+5V

+5V

3.2

0.3

0

0

0

3.2

4.8

3.2

2.6

2.9

4.8

4.8

0.2

0.4

4.9

4.9

4.6

2.2

2.7

2.8

2.82.2

2.7

3.0

4.8

4.8

0.3

0.2

0.2

0.8

1.0

2.4

0.7

0.2

1.0

0.2

3.1

3.4

4.2

4.6

B

R

G

B-Y

Y

R-Y

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

12

34

56

78 9

10

11

12

13

14

15

16

12

34

56

78 9

10

11

12

13

14

15

16

12

3 45

A1

A2

A3

A4

A5

A6

A7

A8

A9

A10

A11

A12

A13

A14

A15

A16

A17

A18

A19

A20

A21

A22

A23

A24

A25

A26

A27

A28

A29

A30

A31

A32

A33

A34

B1

B2

B3

B4

B5

B6

B7

B8

B9

B10

B11

B12

B13

B14

B15

B16

B17

B18

B19

B20

B21

B22

B23

B24

B25

B26

B27

B28

B29

B30

B31

B32

B33

B34

A35

B35

A1

B1

A2

B2

A3

B3

A4

B4

A5

B5

A6

B6

A7

B7

A8

B8

A9

B9

A10

B10

A11

B11

A12

B12

A13

B13

A14

B14

A15

B15

A16

B16

A17

B17

A18

B18

A19

B19

A20

B20

A21

B21

A22

B22

A23

B23

A24

B24

A25

B25

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

12

34 5

67

8

12

34 5

67

8

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

A1

B1

A2

B2

A3

B3

A4

B4

A5

B5

A6

B6

A7

B7

A8

B8

A9

B9

A10

B10

A11

B11

A12

B12

A13

B13

A14

B14

A15

B15

A16

B16

A17

B17

A18

B18

A19

B19

A20

B20

A21

B21

A22

B22

A23

B23

A24

B24

A25

B25

TH201

D402

D401

D403

D404

D406

C401

C402

C403

C404

C405

C408

C410

C411

C412

C413

C414 C415

C416

C417

C418

C419

C421C422

C423

C424C425

C426

C427

C428

C431

C432

C433

C434

C435

C436

C438

C440

R402

R403

R404

R405

R406

R407R408

R409

R410 R412

R414

R415

R416

R419

R422

R423

R424

R425

R426

R427

R432

R438R439

R441

R442

R443R444

R449

R450

R453

IC401(1/6) IC401(2/6)

IC401(3/6) IC401(4/6)

IC401(5/6)

IC401(6/6)

IC402

IC403

IC405

IC406

CN404

FB401

FB402FB403

FB404

C437

R532

R533

JL401

JL402

JL403

JL404

JL405

JL406

JL407

JL408

JL409

JL410

JL411

JL412

JL413

JL414

JL415

JL416

JL417

JL418

JL419

JL420

JL421

JL422

JL423

TP401

TP402

TP403

TP404

TP405

IC404

CN405

R431

R401

C429

R437

R588

D412D411D410

C567

R587

JL486

JL487

R448

JL488

FB408

JL489

C439

C571

C430

D414

C572

R595

D413

R594

R433

R445

R435

R451

R436

R447

R440

R452

C499

C500

R420

C409

C502

R428R429R430

CN403

R413

R418

R411

JL490

JL491

JL492

JL494JL493

R531

R597

C406

C407

C560

C581

R446

R434

R589

R592

R593

R591

C441

R596

FB409D415 R590

CN402

CN401

IC430

R421

C420

R417

IC407

Q401

Q402

IC429

Q405

0:CHIP

#

#

3.3k1/16W:CHIP

0.1

16V

B:CHIP

0.1

16V

B:CHIP

#

#

0.1

16V

B:CHIP

0.1

16V

B:CHIP

47

1/16W

:CHIP

47

1/16W

:CHIP

47

1/16W

:CHIP

0.01

25V

B:CHIP

0.01

25V

B:CHIP

0.01

25V

B:CHIP

0

:CHIP

MA157-TXPROTECT

MA157-TXPROTECT

47

16V

:AL-CP

47

16V

:AL-CP

47

16V

:AL-CP

MA157-TXPROTECT

MA157-TXPROTECT

MA157-TXPROTECT

#

#

74VHC240MTCXINV SW

74VHC14MTCXINV

74VHC14MTCXINV

74VHC221AMTCXMONO MULTI

100p

CH:CHIP

CXA1875AMDAC

74VHC14MTCXINV

74VHC14MTCXINV

74VHC14MTCXINV

100p

CH:CHIP0.1

16V

B:CHIP

1k

1/16W

:CHIP

10k

1/16W

:RN-CP

10k

1/16W

:CHIP

100

1/16W

:CHIP

100

1/16W

:CHIP

10k

1/16W

:CHIP

1.5k

1/16W

:RN-CP

10k

1/16W

:CHIP

100

1/16W

:CHIP

100

1/16W

:CHIP

74VHC14MTCXINV

0.1

16V

B:CHIP

101/16W:CHIP

47

1/16W

:CHIP

4.710V

B:CHIP

4.710V

B:CHIP

4.710V

B:CHIP

4.710V

B:CHIP

0.1

16V

B:CHIP

0.1

16V

B:CHIP

0.1

16V

B:CHIP

100p

CH:CHIP100p

CH:CHIP

3300p

B:CHIP

0

:CHIP

#

#

#

#

220pCH:CHIP

0.0125V

B:CHIP

226.3V:AL-CP

0.06816V

B:CHIP

HD15P

471/16W:CHIP

471/16W:CHIP

471/16W:CHIP

82:RN-CP

82:RN-CP

82:RN-CP

471/16W:CHIP

471/16W:CHIP

#

#

#

100 1/16W :CHIP

100 1/16W :CHIP

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

TC7SH08FUAND

M52758FPVIDEO SW

1016V

:AL-CP

10k

1/16W

:CHIP

32PWHT

47 1/16W :CHIP

47k

1/16W

:CHIP

4.710V

B:CHIP

BK2125HM601T

BK2125HM102TBK2125HM102T

BK2125HM102T

1201/16W:CHIP

RD5.6SB-T1 RD5.6SB-T1 RD5.6SB-T1

0.1

16V

B:CHIP

#

#

150

1/16W

:CHIP

#

#

#

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

1SS355TE-17

15k:CHIP

15k:CHIP

0.116V

B:CHIP

470:CHIP

1SS355TE-17

470

:CHIP

1k

1/16W

:CHIP

1k

1/16W

:CHIP

1k

1/16W

:CHIP

1k

1/16W

:CHIP

1k

1/16W

:CHIP

1k

1/16W

:CHIP

0:CHIP

0:CHIP

100p

CH:CHIP

100p

CH:CHIP

0.1

16V

B:CHIP

100p

CH:CHIP

100

1/16W

:CHIP

100

1/16W

:CHIP

100

1/16W

:CHIP

50P

560

:CHIP

560

:CHIP

#

#

#

##

100 1/16W :CHIP

1k

1/16W

:CHIP

0.1

16V

B:CHIP

47k

:RN-CP

4.7k

1/16W

:RN-CP

2200pB:CHIP

47k

:CHIP

220 :CHIP

476.3V:AL-CP

476.3V:AL-CP

100 1/16W :CHIP

1001/16W:CHIP

471/16W:CHIP

471/16W:CHIP

#

#

#RD5.6SB-T1100k

:CHIP

50P

70P

TC7W14FUINV.

560

:CHIP

0.1

16V

B:CHIP

100

1/16W

:CHIP

M52347SYUNCSYNC SEP

HN1B01FU-TLIMITER

HN1B01FU-TLIMITER

24LC21AT/SNDDC 2SA1611-T1-M5M6

POWER SW.

OTHER/RGB

OTHER/15K

5V-3

5V-3

V-R

V-G

V-B

CLAMP

B-YR-YY

R

G

B

VSI

V-HD

V-CLP

SCL

SDA

5V-2

COAST

3.3V-2

PAL V

A-L

A-R

3.3V-2

3.3V-3

NF OFF

NR OFF

5V-3

5V-2

U-DA

U-CL

15K-CS

HSI

SCL

SDA

R-Y

Y

B-Y

V-R

V-G

V-B

V-HD

V-VD

V-CLP

KEY-TH

LED

SDA

SCL

F+5V

F-DA

F-CL

LAMP COVER

FILTER COVER

SIRCS

5V

3.3V

5V-3

A-R

A-G

A-L

SDAT

SCLK

DAC CS

AUDIO CS

AUDIO MUTE

LAMP SENS

FAN PROT

FAN CONT1

POWER ON

LAMP ON

EXT SW

TXD

RXD

PAL V

A-G

15K-CS

3.3V-2

5V

5V-2

PWR PROT

FAN CONT2

5V-3

USB REQ

LVDS

V-VD

5V

1 2

3 4 5

6

9 8

13

12

11

10

14

7

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

POWER LED

TEMP LED

LAMP LED

PSAVE LED

LAMP TEMP

KEY0

KEY1

PANEL TEMP

TA-

TA+

TB-

TB+

TC-

TC+

TCLK-

TCLK+

TD-

TD+

H.STATE

V.STATE

GREENIN

GND

C/H

VTIMING

V IN

V DET

C/H DET

GATESW

V.POL

H.POL

CLAMP

VCC

CLAMP

TIMING

VS/S IN

VS/S OUT

HD

HD

CLAMPSW

VD

INPUT-A

VCC1(G)

N.C.

IN1(G)

IN1(H)

IN1(V)

GND

GND

IN2(G)

N.C.

GND

IN2(H)

IN2(V)

GND

N.C.

N.C.

VCC2(G)

OUT(G)

GND

GND

OUT(SONG)

VCC

N.C.

OUT(H)

OUT(V)

GND

SW

VCC1(R)

IN1(R)

VCC1(B)

IN1(B)

VCC2(R)

OUT(R)

OUT(B)

VCC2(B)

IN2(R)

IN2(B)

A+5V

A+5V

GND

GND

A+3.3V

GND

D+5V

D+5V

GND

GND

D+3.3V

D+3.3V

GND

GND

SUB+5V

SUB+5V

GND

GND

SUB+3V

SUB+3V

GND

SDA

SCL

GND

GND

A-R

A-G

A-L

A+5V

A+5V

GND

GND

A+3.3V

GND

D+5V

D+5V

GND

GND

D+3.3V

D+3.3V

GND

GND

SUB+5V

SUB+5V

GND

GND

SUB+3V

SUB+3V

GND

SDA

SCL

LAMPC

GND

GND

A-R

A-G

A-L

GND

R-Y

GND

Y

GND

B-Y

GND

PALV

GND

15-CS

GND

GND

V-G

GND

V-B

GND

V-HD

V-VD

V-CLP

V-R

GND

R-Y

GND

Y

GND

B-Y

GND

PALV

GND

15-CS

GND

GND

V-G

GND

V-B

GND

V-HD

V-VD

V-CLP

V-R

F-CL

F-CL

F-DA

F-DA

F+5V

F+5V

U-DA

U-CL

GND

GND

GND

GND

GND

GND

GND

GND

GND

NF OFF

NR OFF

FILC

SIRCS

-1

-1

R

B

G

VSI

HSI

A-G

A-L

GND

SDAT

GND

SCLK

GND

GND

GND

A+5V

A+5V

GND

D+5V

GND

D+3.3V

GND

SUB+5V

GND

RXD

A-G

A-L

GND

SDAT

GND

SCLK

GND

GND

A+5V

A+5V

GND

D+5V

GND

D+3.3V

GND

SUB+5V

GND

GND

TXD

EXT SW

FAN ON

LAMP ON

POWER ON

FAN CONT1

FAN PROT

LAMP SENS

AUDIO CS

DAC CS

AUDIO MUTE

A-R

A-R

-1

PWR PROT

FAN CONT2

USB REQ

GND

KEY1

GND

GND

GND

SDA

GND

GND

GND

GND

GND

GND

GND

GND

SCL

LCD TEMP

LAMP TEMP

KEY0

PSAVE LED

LAMP LED

TEMP LED

POWER LED

TD+

TD-

TCLK+

TCLK-

TC+

TC-

TB+

TB-

TA+

TA-

-1

TO (1/4)

TO (4/4)

FROM (4/4)

FROM (4/4)

FROM (1/4)

TO QA BOARD CN103

TO QA BOARD CN105

TO(2/4),(4/4)

TO(1/4)

FROM(4/4)

FROM(4/4)

TO C BOARD CN801

FROM (4/4)

FROM (4/4)

FROM (4/4)

FROM (4/4)

FROM (4/4)

TO(1/4)

TO(1/4)

TO(2/4)

TO(2/4),(4/4)

TO(1/2)

TO(2/4)

TO (2/4)

TO(1/4)

TO(1/4)

TO(1/4)

B-SS1697<08.>-B..-P1

B(1/4)(R,G,B INPUT,SYNC SEP.)

2CLR

VCC

1R/C

1C

1Q

2B

1A

1B

1CLR

2Q

2C

2R/C

GND 2A

1

2

Q

Q

VCC

SCL

SDA

SDA2

SDA1

SDA0

SW3

SW2

SW1

SW0

DAC4

GND

DAC3

DAC2

DAC1

DAC0

NC1

NC2

NC3

GND

VCC

VCLK

SCL

SDA

TO C BOARD CN803

TO (1/4)

• Refer to page 8-9 for Printed Wiring Board• Refer to page 8-9 for Waveforms• Refer to page 8-9 for IC Block Diagrams

8-11 8-11

A B C D E F G H

1

2

3

4

5

VPL-CS1

B (2/4) B (2/4)

6

+3.3V

+3.3V

+3.3V

+3.3V

+3.3V

+3.3V

+3.3V+3.3V

+3.3V+3.3V

3.3

0.2

3.2

0.6

1.8

2.7

0

0

5.0

3.2

0.2

4.0

3.3

5.0

3.3

B

R

G

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

103

104

105

106

107

108

109

110

111

112

113

114

115

116

117

118

119

120

31

32

121

122

123

124

125

126

127

128

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

65

66

67

68

69

70

71

72

73

74

75

76

77

78

79

80

81

82

83

84

85

86

87

88

89

90

91

92

93

94

95

96

97

98

99100101102

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

4142434445464748495051525354555657585960

61

62

63

64

65

66

67

68

69

70

71

72

73

74

75

76

77

78

79

80

12

34 5

67

8

12

34

56

7 89

10

11

12

13

14

12

34

56

7 89

10

11

12

13

14

C453

C442

C444

C445C446 C447

C448 C449

C450

C451

C452

C454C455

C456

C457

C458

C459

C461

C462

C463

C464

C465

C466

C467

C468

C469 C470

C472 C473 C474

R454

R455

R456R458

R459

R462

R464

R466

R467

R468

R469

R470

R471

R473

FB405

FB406

FB407

RB402

RB403

RB404

RB405

RB406

RB407

RB408

RB409

RB410

RB411

RB412

R465

R463

R461

R460

IC408

R530

R535

R472

JL424

JL425

JL426

JL427

JL428

TP406

R529

R554

IC411

R474

C471 C475

RB401

C460

R534

R457

R567R566

R574

R575

C443

L401

IC409

IC412

IC410

0.116V

B:CHIP

3.3k1/16W:CHIP

3.3k1/16W:CHIP

10k1/16W:CHIP

10k 1/16W :CHIP

10k 1/16W :CHIP

10k 1/16W :CHIP

10k 1/16W :CHIP

10k 1/16W :CHIP

10k 1/16W :CHIP

#

#

0.116V

B:CHIP

0.116V

B:CHIP

221/16W:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.1

16V

B:CHIP

10k 1/16W :CHIP

22

1/16W

:CHIP

226.3V

:AL-CP

0.06816V

B:CHIP

0.0125V

B:CHIP

0.06816V

B:CHIP

0.0125V

B:CHIP

0.06816V

B:CHIP

0.0125V

B:CHIP

471/16W:CHIP

471/16W:CHIP

10k 1/16W :CHIP

10k 1/16W :CHIP

10k 1/16W :CHIP

10k 1/16W :CHIP

TC74LCX74FT

10k

1/16W

:CHIP

100

1/16W

:CHIP

#

#

#

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.1 16V B:CHIP0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.1 16V B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

1001/16W:CHIP

10k

1/16W

:CHIP

10k 1/16W :CHIP

74VHC125MTCXBUF

1.2k

:RN-CP

0.01

25V

B:CHIP

0.22

10V

B:CHIP

0.116V

B:CHIP

100*4

100*4

100*4

100*4

100*4

100*4

100*4

100*4

100*4

100*4

100*4

100*4

0.1 16V B:CHIP

100

1/16W

:CHIP

#

4.7k

1/16W

:CHIP

4.7k

1/16W

:CHIP

BK2125HM601T

BK2125HM601T

BK2125HM601T

#

#

6.8µH

476.3V:AL-CP

AD9884AD CONVERTER

CXD8774RAPA

SN74CBTD3306BUS SW

R

G

CLAMP

B AD

G AD

B

COAST

B AD

R AD

HSI

VSI

PICLK

SRX

SDAT

APA CS

SCLK

3.3V-2

3.3V-2

3.3V-3

SDA

SCL

5V-2

PIHS

PIVS

POFLD

3.3V-2

B NEW0

B NEW1

B NEW2

B NEW3

B NEW4

B NEW5

B NEW6

B NEW7

B OLD0

B OLD1

B OLD2

B OLD3

B OLD4

B OLD5

B OLD6

B OLD7

G OLD0

G OLD1

G OLD2

G OLD3

G OLD4

G OLD5

G OLD6

G OLD7

G NEW0

G NEW1

G NEW2

G NEW3

G NEW4

G NEW5

G NEW6

G NEW7

R NEW0

R NEW1

R NEW2

R NEW3

R NEW4

R NEW5

R NEW6

R NEW7

R OLD0

R OLD1

R OLD2

R OLD3

R OLD4

R OLD5

R OLD6

R OLD7

B NEW7

B NEW6

B NEW5

B NEW4

B NEW3

B NEW2

B NEW1

B NEW0

B OLD7

B OLD6

B OLD5

B OLD4

B OLD3

B OLD2

B OLD1

B OLD0

NC

NC

NC

NC

VD

GND

GND

VD

GND

VD

VD

GND

GND

GND

VD

GND

VD

VD

GND

GND

VD

GND

VD

GND

CKINV

CLAMP

SDA

SCL

A0

A1

PVD

PVD

GND

NC

NC

VDD

GND

DBB0

DBB1

DBB2

DBB3

DBB4

DBB5

DBB6

DBB7

VDD

GND

GND

GND

PVD

GND

PVD

GND

NC

FILT

CKEXT

PVD

GND

COAST

HSYNC

GND

DRB0

DRB1

DRB2

DRB3

DRB4

DRB5

DRB6

DRB7

VDD

GND

DGA0

DGA1

DGA2

DGA3

DGA4

DGA5

DGA6

DGA7

VDD

GND

DGB0

DGB1

DGB2

DGB3

DGB4

DGB5

DGB6

DGB7

VDD

GND

DBA0

DBA1

DBA2

DBA3

DBA4

DBA5

DBA6

DBA7

VD

REFIN

REFOUT

PWRDNB

VD

GND

GND

GND

VDD

GND

NC

HSOUT

DATACK/

DATACK

VDD

GND

DRA0

DRA1

DRA2

DRA3

DRA4

DRA5

DRA6

DRA7

VDD

GND

R IN

G IN

B IN

VSS

HDXOUT

VPD

SDOO

FLDOUT

FLDIN

NC

NC

NC

VDD

XACK

BCK

XTCK

SCLK

SCSIN

SDOOUT

SDIIN

HDXIN

SELECT0

CLK

VSS

DIN27

DIN26

DIN25

DIN24

DIN23

DIN22

DIN21

DIN20

DIN17

VSS

DIN16

DIN15

DIN14

DIN13

DIN12

DIN11

OUT10

OUT9

VSS

OUT8

OUT7

OUT5

OUT6

OUT4

OUT3

OUT2

OUT1

OUT0

VDD

NC NSM

XTST

SDIO

VDXOUT3

VDXOUT2

VDXOUT1

DIN10

OUT11

VDX

VSS

DIN47

RESET IN

VSS

DIN30

DIN31

DIN32

DIN33

DIN34

DIN35

DIN36

DIN37

DIN40

DIN41

DIN42

DIN43

DIN44

DIN45

DIN46

SELECT1 VDXOUT0

1A

2AGND

VCC

EO

OE1

2

1B 2B

PICLK

FROM (1/4)

TO (3/4)

TO (3/4)

TO (3/4)

FROM (3/4)

TO (3/4)

TO (3/4)

FROM (4/4)

TO (3/4)

TO (3/4)

FROM (1/4)

FROM (4/4)

FROM (4/4)

FROM (1/4)

FROM (1/4)

B-SS1697<08.>-B..-P2

(A/D CONVERTER)

B(2/4)

1A

1Y

2A

2Y

GND

VCC

4A

4Y

3A

3Y

1

2

3

4 OE

OE

OE

VCC

2CLR

2D

2CK

2PR

2Q

1D

1CK

1PR

1Q

GND 2

1Q

Q

1CLR


8-12 8-12

A B C D E F G H

1

2

3

4

5

VPL-CS1

0

+3.3V

+3.3V

+3.3V

+3.3V

+3.3V

+3.3V+3.3V

+3.3V

+3.3V

+3.3V

+3.3V

+3.3V

4.0

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50 51 52 53 54 55 56 57 58 59 60

65

66

67

68

69

70

71

72

73

74

75

76

77

78

79

80

81

82

83

84

85

86

87

88

89

90

91

92

93

94

95

96

97

98

99

100

101

102

103

104

105

106

107

108

109

110

111

112

113

114

115

116

117

118

119

120

61 62 63 64

121

122

123

124

125

126

127

128

129130131132133134135136137138139140141142143144145146147148149150151152153154155156157158159160161162163164165166167168169170171172173174175176177178179180181182183184185186187188189190191192

193

194

195

196

197

198

199

200

201

202

203

204

205

206

207

208

209

210

211

212

213

214

215

216

217

218

219

220

221

222

223

224

225

226

227

228

229

230

231

232

233

234

235

236

237

238

239

240

241

242

243

244

245

246

247

248

249

250

251

252

253

254

255

256

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

12

3 45

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

RB413RB414

RB415RB416

RB417

RB418

C477C478

C479C480

C481

C482

C483

C484

C486

C489C490

C491

C495

C496

C501

C503

C505

C506

C507

C508

C509

C510

C511

C512

C513

C514

C515

C516

C517C518

C520

C521

C522

C523

C524

C525

C526 C527 C528 C529C530

C531 C532 C533

R476

R477

JL429

JL448

JL450

C519

C569

C498

C497

IC417

C485

R478

R536

L404

C579RB526

C574

R576

R577

FB414

C573

R568

C568

C575

RB525

C576

C577

C578

C562

C504

C487

IC414

IC415

IC416

IC413

L0403

L402

IC428

#

221/16W:CHIP

221/16W:CHIP

#

#

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP0.116V

B:CHIP

0.116V

B:CHIP 0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP0.116V

B:CHIP

0.116V

B:CHIP0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.1

16V

B:CHIP

0.1

16V

B:CHIP

10*410*4

10*410*4

10*4

100*4

0.1

16V

B:CHIP

0.1

16V

B:CHIP

0.116VB:CHIP

#

100

1/16W

:CHIP

SCAN CONVERTER

2.2µH

0.01

25V

B:CHIP

100*4

22

6.3V

:AL-CP

BK2125HM601T

0.1

16V

B:CHIP

10k

1/16W

:CHIP

0.1

16V

B:CHIP

0.01

25V

B:CHIP

100*4

0.1

16V

B:CHIP

22

6.3V

:AL-CP

0.1

16V

B:CHIP

0.1

16V

B:CHIP

476.3V:AL-CP

476.3V:AL-CP

100 :CHIP

100 :CHIP

MB81F161622BSDRAM

SDRAM

SDRAM

THC63LVDM83ALVDSLVDS RECEIVER

#

OµH

TC7S04FUINV

3.3V

POVS

POHS

B AD

G AD

R AD

PICLK

PIHS

PIVS

OSD-SIG

POCLK

3.3V-2

SDAT

SRX

SC CS

POFLD

POFLD

SCLK

SC RST

3.3V-2

3.3V-2

POCLK

POVS

3.3V-2

POHS

LVDSMEMCLK

MD1

MD2

MD3

MD4

MD5

MD6

MD7

MD8

MD9

MD10

MD11

MD12

MD13

MD14

MD15

MD16

MD17

MD18

MD19

MD20

MD21

MD22

MD23

MD24

MD25

MD26

MD27

MD29

MD30

MD31

MD32

MD33

MD34

MD35

MD36

MD37

MD38

MD39

MD40

MD41

MD42

MD43

MD44

MD45

MD46

MD47

MA0

MA1

MA2

MA3 MA4

MA5

MA6

MA7

MA8

MA9

MD16

MD17

MD18

MD19

MD20

MD21

MD22

MD23 MD24

MD25

MD26

MD27

MD28

MD29

MD30

MD31

MD32

MD33

MD34

MD35

MD36

MD37

MD38

MD39 MD40

MD41

MD42

MD43

MD44

MD45

MD46

MD47

MD0

MD1

MD2

MD3

MD4

MD5

MD6

MD7 MD8

MD9

MD10

MD11

MD12

MD13

MD14

MD15

MA0

MA1

MA2

MA3 MA4

MA5

MA6

MA7

MA8

MA9

MA0

MA1

MA2

MA3 MA4

MA5

MA6

MA7

MA8

MA9

MA0

MA1

MA2

MA3

MA4

MA5

MA6

MA7

MA8

MA9

MD0

MD28

B OLD0

B OLD1

B OLD2

B OLD3

B OLD4

B OLD5

B OLD6

B OLD7

B NEW0

B NEW1

B NEW2

B NEW3

B NEW4

B NEW5

B NEW6

B NEW7

G NEW7

G NEW6

G NEW5

G NEW4

G NEW3

G NEW2

G NEW1

G NEW0

G OLD7

G OLD6

G OLD5

G OLD4

G OLD3

G OLD2

G OLD1

G OLD0

R NEW6

R NEW5

R NEW4

R NEW3

R NEW2

R NEW1

R NEW0

R OLD7

R OLD6

R OLD5

R OLD4

R OLD3

R OLD2

R OLD1

R OLD0

OSDDT0

OSDDT1

OSDDT2

OSDDT3

OSDEN

MA10

MA10

MA10

MA10

R NEW7

B03

B02

B01

B00

G07

G06

G05

G04

G03

G02

G01

G00

R07

R06

R05

R04

R03

R02

R01

R00

B04

B05

B06

B07

TA-

TA+

TB-

TB+

TC-

TC+

TCLK-

TCLK+

TD-

TD+

B07

B06

B05

B04

B03

B02

B01

B00

G07

G06

G05

G04

G03

G02

G01

G00

R07

R06

R05

R04

R03

R02

R01

R00

SO

GND

VDD

MD0

MD1

MD2

MD3

MD4

VDD

MD5

MD6

MD7

MD8

GND

VDD

MD9

MD10

MD11

MD12

MD13

GND

VDD

MD14

MD15

MD16

MD17

MD18

GND

VDD

MD19

MD20

MD21

MD22

MD23

GND

VDD

MD24

MD25

MD26

MD27

MD28

GND

VDD

MD29

MD30

MD31

MD32

GND

MD33

VDD

MD34

MD35

MD36

MD37

GND

VDD

MD38

MD39

MD40

MD41

GND

MD42

VDD

MD43

MD44

MD45

MD46

GND

MD47

VDD

BA1

BA0

MA0

MA1

MA2

MA3

GND

VDD

MA4

MA5

MA6

MA7

MA8

MA9

MA10

MA11

VDD

GND

GND

GND

POFLD

POD0

GND

POD1

VDD

POD2

POD3

POD4

POD5

GND

POD6

VDD

POD7

POD8

POD9

POD10

GND

VDD

POD11

POD12

POD13

POD14

GND

POD15

VDD

POD16

POD17

POD18

POD19

GND

VDD

POD20

POD21

POD22

POD23

POD24

GND

VDD

POD25

POD26

POD27

POD28

POD29

GND

VDD

POD30

POD31

POD32

POD33

POD34

GND

VDD

POD35

POD36

POD37

POD38

POD39

GND

VDD

POD40

POD41

POD42

POD43

GND

POD44

VDD

POD45

POD46

POD47

GND

VDD

PID0

PID1

PID2

PID3

PID4

PID5

PID6

PID7

PID8

PID9

GND

PID10

VDD

PID11

PID12

PID13

PID14

PID15

PID16

PID17

PID18

PID19

GND

VDD

PID20

PID21

PID22

PID23

PID24

PID25

PID26

PID27

PID28

PID29

GND

PID30

PID31

PID32

PID33

PID34

PID35

PID36

PID37

PID38

PID39

PID40

GND

VDD

PID41

PID42

PID43

PID44

PID45

PID46

PID47

GND

PICLK

VDD

PIFLD

PIVSGO

SCLK

SS

SI

GND

VDD

VDD

DQ0

DQ1

VSSQ

DQ2

DQ3

VDDQ

DQ4

DQ5

VSSQ

DQ6

DQ7

VDDQ

LDQM

CS

BA

A10/AP

A0

A1

A2

A3

VDD

RAS

VSS

DQ15

DQ14

VSSQ

DQ13

DQ12

VDDQ

DQ11

DQ10

VSSQ

DQ9

DQ8

VDDQ

N.C/RFU

UDQM

CLK

CKE

N.C

A9

A8

A7

A6

A5

A4

VSS

CAS

VDD

DQ0

DQ1

VSSQ

DQ2

DQ3

VDDQ

DQ4

DQ5

VSSQ

DQ6

DQ7

VDDQ

LDQM

CS

BA

A10/AP

A0

A1

A2

A3

VDD

RAS

VSS

DQ15

DQ14

VSSQ

DQ13

DQ12

VDDQ

DQ11

DQ10

VSSQ

DQ9

DQ8

VDDQ

N.C/RFU

UDQM

CLK

CKE

N.C

A9

A8

A7

A6

A5

A4

VSS

CAS

VDD

DQ0

DQ1

VSSQ

DQ2

DQ3

VDDQ

DQ4

DQ5

VSSQ

DQ6

DQ7

VDDQ

LDQM

CS

BA

A10/AP

A0

A1

A2

A3

VDD

RAS

VSS

DQ15

DQ14

VSSQ

DQ13

DQ12

VDDQ

DQ11

DQ10

VSSQ

DQ9

DQ8

VDDQ

N.C/RFU

UDQM

CLK

CKE

N.C

A9

A8

A7

A6

A5

A4

VSS

CAS

GND

WE

WE

WE

MCLK

VDD

MCLKSEL

TESTH

POCLK

AVDD

VDD

CS

DQMO

DQM1

CAS

RAS

MWR

RST

TEST0

TEST1

PODMD

OSDEN

AGND

OSDDT1

OSDDT2

OSDDT3

POVS

POHS

POEXT

POACT

PIVS

PIHS

OSDDT0

TO P3,P4

TO P2,P3

FROM (4/4)

FROM (4/4)

TO (4/4)

FROM (2/4)

FROM (2/4)

TO(2/4)

B-SS1697<08.>-B..-P3

B(3/4)SCAN CONVERTER,SDRAM,LVDS RECEIVER

FROM (2/4)


B (3/4) B (3/4)

8-13 8-13

A B C D E F G H

1

2

3

4

5

VPL-CS1

0

+5V

5.0

4.35.0

3.3

5.0

5.01.6

1.5

1.6

1.4

1.5

1.5

1.6

1.5

0

0

3.3

4.9 3.3

5.0

3.3

4.9

3.3

4.9

+3.3V

+3.3V

+3.3V

+5V

+5V

+3.3V

0

0 0

0

3.1

3.2

1.0

0.9

3.0

3.1

1.4

1.0

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

57

58

59

60

616263646566676869707172737475767778798081828384858687888990

91

92

93

94

95

96

97

98

99

100

101

102

103

104

105

106

107

108

109

110

111

112

113

114

115

116

117

118

119

120

12 3

412 3

4

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

12

3 45

12

34

56

7 89

10

11

12

13

14

12

34 5

67

8

1

2

3

4

5

6

7

8

1 2 3 4

5678

12

34

56

7 89

10

11

12

13

14

VDD

OUTGND

OE/ST

VDD

OUTGND

OE/ST

R500

D408D409

C534

C535C536

C537

C538 C539 C540 C541

C542

C543

C544

C545C546 C547C548 C549

C550

C551

C552

C553

C554

C555

C556

C557

C559

C561

C563

C564

C565C566

R479

R480

R481

R482

R483

R485

R486

R487

R488

R489

R490

R495

R496

R497

R501

R502

R504

R506

R511

R512

R513

R514

R515

R516

R517 R518

R519R520

R521

R522

R523

R526R527R528

Q404

IC418

IC419 IC420

IC421

IC427

FB410

FB411

FB412

FB413

X401

X402

R537 R538 R539

R540

R542

R543

R545

R546

R547

R550

R551

RB520

R549 R548

RB521

R509

R552

R553

C558

R492

RB522

RB523

RB524

JL453

JL454

JL455

JL456

JL457

JL458

JL459

JL460

JL461

JL462

TP407

R510

R484

JL468

R544

C570

R557

R558 R559

R503

R556

R555

R525R524

JL470

JL471

JL472

JL473

JL474

JL475

JL476

JL477

JL478

JL479

JL480

JL481JL482

R560R561

JL483

JL484

JL485

R562

RB419

R563

R564 R565

R491

R541

R508

R507

JL466

JL469

JL463

R583R584

R498

R499

JL433

IC422

R585

CN406

R505

IC424

X403

JL464

JL465

JL467

JL451JL452

Q403

IC426

IC423

IC425(4/8)

IC425(1/8)

IC425(3/8)

IC425(2/8)

IC425(8/8)

IC425(5/8)

IC425(7/8)

IC425(6/8)

10pCH:CHIP

10p

CH:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

10k1/16W:CHIP

33k1/16W:CHIP

33k1/16W:CHIP

47k1/16W:CHIP

10k1/16W:CHIP

0:CHIP

1001/16W:CHIP

1001/16W:CHIP

1001/16W:CHIP

1001/16W:CHIP

10k1/16W:CHIP

10k1/16W:CHIP

1001/16W:CHIP

1001/16W:CHIP

0.0125V

B:CHIP

0.0125V

B:CHIP

110V

F:CHIP

110V

F:CHIP

2SC2712-YGRES SW

10k

1/16W

:CHIP

10k

1/16W

:CHIP

10k

1/16W

:CHIP

100

1/16W

:CHIP

100

1/16W

:CHIP

100

1/16W

:CHIP

0.116V

B:CHIP

100

1/16W

:CHIP

100

1/16W

:CHIP

47

1/16W

:CHIP

47

1/16W

:CHIP

0.1

16V

B:CHIP

0.1

16V

B:CHIP

22

1/16W

:CHIP

0.116V

B:CHIP

0.1

16V

B:CHIP

1001/16W:CHIP

0.1

16V

B:CHIP

S-80828ANNPRESET

100

1/16W

:CHIP

100

1/16W

:CHIP

226.3V:AL-CP

226.3V:AL-CP

#

100pCH:CHIP

226.3V:AL-CP

1k1/16W:CHIP

221/16W:CHIP

1k1/16W:CHIP

471/16W:CHIP

471/16W:CHIP

SG-8002JCPCC70MHzXTAL

10k

1/16W

:CHIP

10k

1/16W

:CHIP

10k

1/16W

:CHIP

100

1/16W

:CHIP

100 1/16W :CHIP

100 1/16W :CHIP

100 1/16W :CHIP

100 1/16W :CHIP

100 1/16W :CHIP

10k

1/16W

:CHIP

10k

1/16W

:CHIP

100

1/16W

:CHIP

100

1/16W

:CHIP

#

#

#

#

#

#

#

#

10k

1/16W

:CHIP

#

100

1/16W

:CHIP

#

#

10k

1/16W

:CHIP

0.116V

B:CHIP

0.116V

B:CHIP

470pCH:CHIP

226.3V:AL-CP

TC7W08FUAND

200:RN-CP

3k:RN-CP

22 1/16W :CHIP

#

SG-8002JCPCC52MHzXTAL

22

1/16W

:CHIP

#

100

1/16W

:CHIP

100

1/16W

:CHIP

#

#

#

#

#

#

#

#

#

#

#

##

10k

1/16W

:CHIP

10k

1/16W

:CHIP

#

#

#

2.2k1/16W:CHIP

2.2k1/16W:CHIP

2.2k1/16W:CHIP

2.2k1/16W:CHIP

2.2k1/16W:CHIP

1k1/16W:CHIP

100 1/16W :CHIP

TC74LCX04FTINV

0:CHIP

100*4

100*4

100*4

100*4

100*4

10k

1/16W

:CHIP

10k

1/16W

:CHIP

10k

1/16W

:CHIP

100

1/16W

:CHIP

47*4

100 1/16W :CHIP

#

#

#

1001/16W:CHIP

1001/16W:CHIP

S-80842ANNPRESET

100 1/16W :CHIP10k

1/16W

:CHIP

#

22

1/16W

:CHIP

#

#

10

1/16W

:CHIP

BK2125HM601T

BK2125HM601T

BK2125HM601T

BK2125HM601T

HD64F2633MAIN CPU

DAN202K-T-146DAN202K-T-146

2.2k

1/16W

:CHIP

8PWHT:SMD

MB90098OSD

XTAL12.288MHz

#

#

#

##

2SB798-DLRES SW

NC7SZ86P5XEX OR

74VHCT04MTCXINV

TC74LCX541FT(EL)BUFF

TC74LCX541FT(EL)BUFFTC74LCX541FT(EL)

BUFF






3.3V

CPU_RES

FWE

CPU_RES

FWE

3.3V

SIRCS

POVS

POVS

POHS

POCLK

MEMCLK

5VF+5V

5V

SRX

5V

HSI

VSI

5V

F-CL

F-DA

5V

RXD

TXD

FILTER COVER

LAMP COVER

KEY-TH

SCLK

SDAT

F-CL

F-DA

EXT SW

AUDIO CS

DAC CS

APA CS

SC CS

LED

POWER ON

LAMP ON

LAMP SENS

FAN PROT

FAN CONT1

AUDIO MUTE

NR OFF

NF OFF

3.3V-2

3.3V-2

5V-2

5V

SC RST

3.3V-2

3.3V-2

OSD-SIG

3.3V-2

SDA

SCL

5V-2

5V

U-CL

U-DA

3.3V-2

FAN CONT2

PWR PROT

USB REQ

2

187

13

6

145

154

16

317

9 11

1

19

812

20

10

RESN

OSD ON

TRE

KEY0

KEY1

LAMP TEMP

PANEL TEMP

POWER LED

TEMP LED

LAMP LED

PSAVE LED

RESN

TRE

OSDEN

OSD CS

OSDDT0

OSDDT1

OSDDT2

OSDDT3

OSD ON

SCLK(OSD)

SDAT(OSD)

OSD CS

SDAT(OSD)

SCLK(OSD)

PC0

PC1

PC2

VSS

VCC

PC6

VSS

PB0

PVCC1

PB1

PB2

PB3

PB4

PB5

PB6

PB7

PA0

VSS

P10

P11

P12

P13

IRQ0

TCLKC

P16

TIOCB2

PE0

PE1

PE2

PE3

PE4

PE5

PE6

PE7

VSS

PD0

PVCC1

PD1

PD2

PD3

PD4

PD5

PD6

PD7

TXD0

RXD0

PVCC2

SDA1

VSS

SCL1

SDA0

SCL0

RXD4

TXD4

PG0

PG1

PG2

PG3

PG4

PLLVCC

PLLCAP

PLLVSS

NMI

FWE

XTAL

VCC

EXTAL

VSS

OSC1

OSC2

PVCC1

PF7/?

VSS

PF6

PF5

PF4

PF3

PF2

PF1

PF0

AVCC

VREF

AN0/P40

AN1/P41

AN2/P42

AN3/P43

AN4/P44

AN5/P45

DA0/AN6/P46

DA1/AN7/P47

AN8/P90

ANP/P91

AN10/P92

AN11/P93

AN12/P94

AN13/P95

AN14/P96

AN15/P97

AVSS

P70

P71

P72

P73

P74

SCK3

RXD3

TXD3

MD0

MD1

MD2

TXD

RXD

VIN

GND

RES

FWR

MD1

MD2

E0

E1

E2

WC

OUT

VDD

VSS

NC

OUT

VDD

VSS

NC

GND

VCC

SCL

SDA

RES

WDTOVF

TXD2(FWR)

RXD2(FWR)

STBY

FLASH

GND

-1

-1

-1

3.3V-15V-1

-1-1

-1

-1

-1

SIN

SCLK

VSS

DCLK1

VSS

VDD

TCLK1

VDD

DISP

DA0

DA1

DA2

DA3

VOBA

VSS

DCLK0

DB0

DB1

DB2

DB3

VOBB

BISYTEST

RESET

VSYNC

HSYNC

CS

ZOOM

VDD

SCL

SDA-OUT

SDA-IN

SCLK

-1

B-SS1697<08.>-B..-P4

(MAIN CPU)

B(4/4)

TO(1/4)

TO(4/4)TO(3/4)

TO(4/4)

TO(3/4)

TO(3/4)

FROM (3/4)

FROM (3/4)

FROM (4/4)

TO(1/4)

FROM (1/4)

FROM (1/4)

TO (3/4)

TO (1/4)

TO (2/4),(3/4)

FROM (1/4)

TO (1/4)

TO (1/4)

TO (1/4),(2/4)

FROM (3/4)

FROM (1/4)

TO (1/4)

TO (1/4)

TO (3/4)

TO (2/4)

TO (1/4)

TO (1/4),(2/4)

1A

1Y

2A

2Y

3A

3Y

GND

VDD

6A

6Y

5A

5Y

4A

4Y

1A

1Y

2A

2Y

3A

3Y

GND

VDD

6A

6Y

5A

5Y

4A

4Y

B (4/4) B (4/4)• Refer to page 8-9 for Printed Wiring Board• Refer to page 8-9 for Waveforms• Refer to page 8-9 for IC Block Diagrams

8-14 8-14

A B C D E F G H

1

2

3

4

5

VPL-CS1

C C

A B C D E F G

1

2

3

4

A B C D E F G

1

2

3

4

—C—1-675-791-11

D801 G-3D802 ∗ D-4D803 ∗ D-4D804 ∗ C-4D805 ∗ C-4D806 ∗ C-4D807 ∗ C-4D812 G-2D813 G-2D814 G-2

IC801 F-3IC802 F-4IC803 A-2IC804 G-2IC805 B-2IC806 B-3IC807 B-3IC808 C-2IC808 D-2IC810 D-2IC811 C-2IC812 C-1IC813 C-4IC814 B-3IC815 D-3IC817 E-4IC819 G-3IC820 G-3IC821 G-4IC822 D-2

Q801 ∗ A-3Q802 B-4Q803 B-4Q804 C-3Q805 C-3Q807 B-3Q808 B-4Q808 D-3Q809 D-3Q810 G-4Q811 F-4Q812 G-3Q814 ∗ A-3Q815 ∗ A-3Q816 G-4Q817 ∗ A-3Q819 G-3

TP801 G-2TP802 G-2TP803 A-3TP804 A-3TP805 A-3TP806 C-4TP807 E-3TP808 C-2TP809 B-3TP810 E-4TP811 E-4TP812 B-4TP813 B-2TP814 B-2TP815 A-2TP816 A-2

*:B Side mount

C – B SIDE –

SUFFIX ; -11

C – A SIDE –SUFFIX ; -11

8-15 8-15

A B C D E F G H

1

2

3

4

5

VPL-CS1

C (1/5) C (1/5)• Refer to page 8-14 for Printed Wiring Board• Refer to page 8-20 for Waveforms• Refer to page 8-20 for IC Block Diagrams

0

+12V

1

2

3

11.9

2.6

0

0

2.6

2.6

0.6

5.0

5.0

1.8

4.4

2.2

1.8

4.4

2.2

2.2

54

+5V

+16.5V

1.24.8

4.9

5.04.7

4.9

4.94.3

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

GI O

ON/OFF ADJ

1

2

1

2

3

1

2

3

4

5

6

7

8

9

10

11

12

1

2

3

4

5

6

7

8

1

2

3

4

5

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32A1

B1

A2

B2

A3

B3

A4

B4

A5

B5

A6

B6

A7

B7

A8

B8

A9

B9

A10

B10

A11

B11

A12

B12

A13

B13

A14

B14

A15

B15

A16

B16

A17

B17

A18

B18

A19

B19

A20

B20

A21

B21

A22

B22

A23

B23

A24

B24

A25

B25

1

2

3

4

5

123456

EMI

EMI

EMI

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

12

34 5

67

8

EMI I OG

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54

55

56

FL801

JL805

FB802

C802

C821

FB801

FB804

FB805

JL801

JL802

JL803JL804

JL806

JL807

JL808

JL809JL810JL811

JL819

JL820

JL821

JL822

JL823

JL824

JL825

JL826

R801

R802

R803

R804

R805

R806

R843

R846

R847

TH801

TH802

TP801

TP802

D801

C803 C805

C808

C809

C814

C815

C820

C822

C823

C826

C829C831

C832

C834

CN802

CN805

CN806

CN808

D802

D803

D805

D806

D807

R807

R809

R810

R811

R812

R813

R815

R816

R817

R819

R820

R821

R822

R823

R824

R826

R827

R828

R837

R839

R850

R851

D812

D813

D814

R852

CN809

R970

TP813 TP814

IC801

CN803

C807

C812

R833

CN807

R845

R853

R854

TP805

TP804

TP803

IC802

CN804

R844

CN801

R905

D804

R825

JL813

JL877

JL880

JL878

JL869

JL870

JL871

JL872

JL875

JL876

JL881

C804

C835

C836

JL817

C837

C838

C839

JL818

JL882

R911

R912

R913R818

R814

R808

R1000

R1001

R1002

R1003 R1004

R1005 R1006

R1007 R1008

C841

C842

C843

C801

L801

R836L802 C811C810

R1010

R1011

C813

R909R907

JL879

R829

R1012

C816

FL802

FL803

FL804

R1009

JL884

JL885

R840

R835

C830

IC805

IC807

R1021

R1019

R1020

R1018

R1013

R1014

R1015

R1016

R1017

R1022

C970

C968

C971

C851

C828

C817C819

C967

C850

C833

C818

C824

C852

C827

C846

C845

C969

C825

TP815

TP816

TP817

JL883

L814L803 L804

FB803

R831

R830

R832

R841

R834

IC806

Q801

Q814

Q815

Q817

C840

IC803

JL812

Q816

IC804(1/4)

IC804(3/4)

IC804(4/4)

IC804(2/4)

510:RN-CP

8.2k:RN-CP

20k:RN-CP

#

4725V

:AL-CP

NFM41P11C204

#

2PRED:SMD

3PWHT:SMD

#

#

#

##

LCD

#

#

DTZ-TT11-5.1

DTZ-TT11-5.1

DTZ-TT11-5.1

DTZ-TT11-5.1

LAMP

#

#

12PWHT:SMD

#

#

#

#

#

#

#

#

100:CHIP

100:CHIP

100:CHIP

100:CHIP

100:CHIP

100:CHIP

100:CHIP

100:CHIP

0.01B:CHIP

#

0.01B:CHIP

0.01B:CHIP

0.01B:CHIP

0.01B:CHIP

10k:CHIP

4.7k:CHIP

1k:RN-CP1k

:CHIP

#

2.7k:RN-CP

4.7k:CHIP

4.7k:CHIP

1k :CHIP

1k :CHIP

330 :CHIP

330 :CHIP

330 :CHIP

110V

B:CHIP

8PWHT:SMD

0:CHIP

0:CHIP

#

#

#

DTZ-TT11-5.1

4725V

:AL-CP

47

25V

:AL-CP

DTZ-TT11-5.1

47:CHIP

47:CHIP

47:CHIP

47:CHIP

47:CHIP

DTZ-TT11-5.1

DTZ-TT11-5.1

DTZ-TT11-5.1

100 :CHIP

0:CHIP

476.3V

:AL-CP

476.3V

:AL-CP

476.3V

:AL-CP

5PWHT:SMD

PQ20VZ5U15V REG

32PWHT

0.2225V

B:CHIP0.2225V

B:CHIP

470k:CHIP

5PWHT:SMD

BK2125HM601T

BK2125HM601T

BK2125HM601T

BK2125HM601T

0

:CHIP

0

:CHIP

0

:CHIP

BA12FP12V REG

6PWHT:SMD

330 :CHIP

50PWHT

100

:CHIPDTZ-TT11-5.1

100

:CHIP

#

#

#

#

#

#

#

#

#

#

#

100

16V

:AL-CP

#

0.1

25V

B:CHIP

#

#

0.1

25V

B:CHIP

#

#

#

470

:CHIP

470

:CHIP

470

:CHIP

#

#

#

470

:CHIP

470

:CHIP

470

:CHIP

2.2k

:CHIP2.2k

:CHIP

2.2k

:CHIP2.2k

:CHIP

2.2k

:CHIP2.2k

:CHIP

10

16V

:AL-CP

10

16V

:AL-CP

10

16V

:AL-CP

100µH

#10µH

100:CHIP

150

:RN-CP

150

:RN-CP

0.1

25V

B:CHIP

3916V:OS

#

#

47k

:CHIP

10k

:CHIP

ZJSM-R15-180T

ZJSM-R15-180T

ZJSM-R15-180T

150 :RN-CP

#

#

#

#

#

47

6.3V

:AL-CP

560

:CHIP

0

:CHIP

0

:CHIP

22

:CHIP

100

:CHIP

100

:CHIP

100

:CHIP

100

:CHIP

100

:CHIP

3.3k

:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

0.01

B:CHIP

0.01

B:CHIP

0.01

B:CHIP0.01

B:CHIP

0.01

B:CHIP

0.001

B:CHIP

0.001

B:CHIP

0.001

B:CHIP

0.001

B:CHIP

47

6.3V

:AL-CP

47

6.3V

:AL-CP

#

4.7µH2.2µH 2.2µH

BK2125HM601T

75

:RN-CP

22

:CHIP

75

:RN-CP

75

:RN-CP

#

THC63LVDF84ALVDS RECEIVER

µM385MX-1.2REF

4.7k:CHIP

4.7k:CHIP

ADV7123KST140D/A

2SA1462BUFFER

2SA1462BUFFER

2SA1462BUFFER

2SA1462BUFFER

0.1

25V

B:CHIP

M52749FPRGB AMP

#

DTC144EKASW

TC74VHC08FAND

TC74VHC08FAND

TC74VHC08FAND

TC74VHC08FAND

16.5V

15.5V

R OUT

G OUT

B OUT

5V

5V-2 5V

5V

5V-2

AUDIO GND

AUDIO +B

12V

3.3V-2

5V-3

5V-2

5V

A-R

A-L

SDAT

AUDIO-MUTE

AUDIO GND

DALD

APCE

5V-2

CLP

12V

A-SCLKD-SCLK

5V-3

3.3V-2

CLK

HSO

VSO

3.3V-2

5

46

1

23

10

98

14

7

13

1211

POWER ON

KEY0

KEY1

PSAVE LED

LAMP LED

TEMP LED

POWER LED

LAMP ON

LAMP SENS

RXD

TXD

EXT SW

LAMP TEMP

LCD TEMP

FAN PROT

RXD

TXD

EXT SW

LAMP ON

FAN CONT1

FAN PROT

LAMP SENS

POWER LED

TEMP LED

LAMP LED

PSAVE LED

KEY1

KEY0

LAMP TEMP

LCD TEMP

FAN CONT2

POWER ON

FAN CONT1

FAN CONT2

RD+

RD-

RCLK+

RCLK-

RC+

RC-

RB+

RB-

RA+

RA-

RA-

RA+

RB-

RB+

RC-

RC+

RCLK-

RCLK+

RD-

RD+

+15.5V

SUB+5V

SCI

GND

FLAG

POWER CONT

-1

FAN PROT

-1

L CONT IN

L CONT OUT

GND

GND

GND

GND

N.C

KEY0

KEY1

SUB 5V

LAMP LED

POWER LED

D 5V

TEMP LED

-1

GND

AUDIO +B

AUDIO GND

+16.5V

GND

+16.5V

AUDIO GND

AUDIO +B

RGBGND

HD

VD

RXD

TXD

GND

EXT SW

SUB 5V

VISCA

PSAVE LED

M.OUT

N.C.

A-G

A-L

GND

SDAT

GND

SCLK

GND

GND

GND

A+5V

A+5V

GND

D+5V

GND

D+3.3V

GND

SUB+5V

GND

RXD

A-G

A-L

GND

SDAT

GND

SCLK

GND

GND

A+5V

A+5V

GND

D+5V

GND

D+3.3V

GND

SUB+5V

GND

GND

TXD

EXT SW

LAMP ON

FAN CONT1

FAN PROT

LAMP SENS

AUDIO CS

DAC CS

AUDIO MUTE

A-R

A-R

-1

SUB+5V

D+3.3V

A+5V

D+5V

HDVD

+12V

FAN CONT1

FAN CONT2

FAN CONT2B

R

G

POWER ON

B DA

G DA

G0

G1

G2

G4

G5

G6

G7

G8

G9

BLANK

SYNC

VREF

COMP

IOR

IOG

VAA

VAA

IOB

GND

GND

IOR

IOG

IOB

PSAVE

R9

R8

R7

R6

R5

R4

R3

R2

R1

R0

RSET

VAA

B0

B1

B2

B3

B4

B5

B6

B7

B8

B9

CLOCK

R DA

RC3

RD6

RC4

GND

RC5

RC6

RD0

RA-

RA+

RB-

RC-

RC+

RCLK-

RCLK+

RD-

RD+

CLKOUT

RA0

GND

/PDWN

PLL GND

PLL VCC

PLL GND

LVDS GND

LVDS VCC

LVDS GND

LVDS GND

VCC

RC2

RC1

RC0

GND

RB6

RD5

RD4

VCC

RB5

RB4

RB3

GND

RB2

RD3

RD2

VCC

RB1

RB0

RA6

GND

RA5

RD1

RA4

RA3

VCC

RA2

RA1

RB+

TO P2

GND

KEY1

GND

GND

GND

SDA

GND

GND

GND

RD-

GND

RCLK+

GND

GND

GND

RA+

RA-

GND

RC+

RC-

RB+

RB-

RCLK-

RD+

SCL

LCD TEMP

LAMP TEMP

KEY0

PSAVE LED

LAMP LED

TEMP LED

POWER LED

TO P2

G3

TO B BOARD CN403TO B BOARD CN405

TO (5/5)

TO (5/5)

TO (5/5)

TO (3/5)

TO (3/5)

TO (3/5),(5/5)

TO (5/5)

TO (4/5)

TO (3/5)

TO (4/5)

FROM (2/5)

TO H BOARD CN001

TO (5/5)

TO (2/5)

TO GBB BOARD CN706

TO GBA BOARD CN674

TEMP

FUSE

LCD DRIVER,AUDIO AMP

C(1/5)

B-SS1697<08.>-C..-P1

BALAST

LAMP

OSDBLK

RIN

NC

NC

CLP

NC

GND2

NC

GND

GND

BLK

GND

SDA

SCL

VCC1(R)

GND1(R)

G IN

SOG IN

OSD G

GND1(G)

OSD R

B IN

VCC1(B)

OSD B

GND(B)

GND1(B)

ABL IN

VCC 5V

SOG OUT

D/A 5

D/A 4

D/A 3

D/A 2

D/A 1

CONT DAC

B OUT

CONT REF

VCC2

R OUT

G OUT

VCC1(G)

MAIN BRT

8-16 8-16

A B C D E F G H

1

2

3

4

5

VPL-CS1

C (2/5) C (2/5)• Refer to page 8-14 for Printed Wiring Board• Refer to page 8-20 for Waveforms• Refer to page 8-20 for IC Block Diagrams

+5V

2.1

0

0

0.2

0.3

0.1

0.2

0.1

0.3

0.2

0.2

0.1

0.3

0.2

0.2

2.5

0.5

4.4

3.9

0.4

4.2

0.1

3.9

0.4

0.4 4.7

1.83.7

3.8

+5V

2.1

2.5

+5V

+5V

+5V

0

0

0

0

0

0

0

0 0 0 0 0 0 0 0

4.6

5.0

4.7

1.7

4.4

5.9

0.5

4.7

5.0

0.6

5.0

3.5

5.2

3.0

1.5

1.8

5.5

12

34

56

7 89

10

11

12

13

14

12

34

56

7 89

10

11

12

13

14

1

2

3

4

5

6

7

8

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

12

34 5

67

8

EMI

EMI

12

3 45

FB806

FB807

FB808

FB811

IC808

IC810

IC811

JL827 JL828

JL829

JL830

JL831

JL832

JL833

JL834

JL835

JL836

JL837

JL838

JL839

JL840

JL841

JL842

JL843

JL844

JL845

JL846

JL847

C853

C854

C855

C856 C857

C858

C859

C860 C861

C862

C863

FL805

FL806

R855

R856

R857

R858R859

R860

R861

R862

R863

R864

R865

R866

R867

R868

R869

R870

R871

R872

R873

R874

R875

R876

R877

R878

R879

CN810

C962C961

C963

C964

C965

C966IC809

FB809

FB810

IC822(5/6)

IC822(6/6)IC822(3/6)

IC822(1/6)

IC822(4/6)

IC812

TC74VHCT04AFTINVERTER

TC74VHCT04AFTINVERTER

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

#

MC100ELT20PECL DRV

#

#

100:CHIP

100:CHIP

100:CHIP

0.125V

B:CHIP

1k:CHIP

1k:CHIP

100:CHIP

330:CHIP

330:CHIP

47:CHIP

47:CHIP

47:CHIP

47:CHIP

47:CHIP

47:CHIP

47:CHIP

47:CHIP

47:CHIP

47:CHIP

22:CHIP

22:CHIP

110V

B:CHIP

110V

B:CHIP110V

B:CHIP

110V

B:CHIP

110V

B:CHIP

110V

B:CHIP

0:CHIP

0:CHIP

0:CHIP

0:CHIP

0:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

476.3V:AL-CP

476.3V

:AL-CP

8PWHT:SMD

1

10V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

BK2125HM601T

BK2125HM601T

BK2125HM601T

BK2125HM601T

ISPLSI1016E-80LT44-STG

BLM21B750S

BLM21B750S

TC74VHCT04AFT

INVERTER

TC74VHCT04AFT

INVERTERTC74VHCT04AFT

INVERTER

TC74VHCT04AFT

INVERTER

TC74VHCT04AFT

INVERTER

TC7SZ04FU(TE85R)INVERTER

CLP

5V

TP

5V-2

RB DIR

5V-2

VSO

HSO DWN

5V-2

MCLK

MCLK

CLK

3.3V-2

PRG

1 2

14

7

5 69

8

11 10

13 12

VST

VCK

HCK1

HCK2

HST

PCG

ENB

HCK1

HCK1

HCK1

VCK

ENB

VST

VST

ENB

VCK

HCK1B

HCK1G

HCK1R HCK2

HCK2

HCK2

PCG

HST

HST

PCG

HCK2B

HCK2G

HCK2R

FRP

PRG

SCLK

GND

MODE

PLUG

SDI

SDO

VCC

ISPEN

-1

PLD

FROM (1/5)

FROM (1/5)

TO (3/5),(4/5)

TO (3/5)

FROM (3/5)

FROM (3/5)

TO (1/5)

FROM (1/5)

TO (3/5),(4/5)

NC

NC

NC

VCC

GND

D

Q

Q

AUDIO AMP

B-SS1697<08.>-C..-P2

LCD DRIVER,

C(2/5)

1A

1Y

2A

2Y

3A

3Y

GND

VCC

6A

6Y

5A

5Y

4A

4Y

1A

1Y

2A

2Y

3A

3Y

GND

VCC

6A

6Y

5A

5Y

4A

4Y

I/028

I/029

I/030

I/031

Y0

VCC

SDI/INO

I/11

I/01

I/02

ISPEN

I/03

I/04

I/05

I/06

I/07

GND

SDO/IN1

I/08

I/09

I/010

I/011

I/018

I/017

I/016

IN2/MODE

VCC

Y2/SCLK

I/015

I/014

I/013

I/012

RESETY1/

I/027

I/026

I/025

I/024

GOE/IN3

GND

I/023

I/022

I/021

I/020

I/019

PECL

TTL

8-17 8-17

A B C D E F G H

1

2

3

4

5

VPL-CS1

C (3/5) C (3/5)

0

+15.5V

7

+15.5V

6

+5V

+5V

+5V

+5V

+15.5V

0

0

4.8

3.7

3.7

3.4

3.4

3.4

0.4

5.0

4.1

5.0

4.4

5.0

7.0

7.0

7.0

7.0

7.0

7.0

3.3

2.2

7.0

7.0

2.5

3.3

2.4

1.3

6.9

2.0

0

0

0

0

0

1.8

2.5

2.0

2.1

2.2

5.0

2.4

4.8

4.0

0

0

4.7

2.4

2.4

2.4

2.4

2.5

1.8

0.6

15.5

15.5

7.5

6.96.3

6.9

15.5

6.97.5

6.9

7.5

7.5

6.9

7.5

6.9

15.5 7.5

6.9

7.5

6.9

6.5

3.4

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33343536373839404142434445464748

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

12

34

56

78

910

11

12

13

14

15

16

17

18

19

20

12

34

56

78 9

10

11

12

13

14

15

16

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

FB812

IC815

JL848

JL849

JL850

JL851

JL852

JL854

JL855

JL856

L806

L807

TP806

TP807

TP808

C864 C865

C866

C867

C868

C869C870C871

C873

C874

C875

C876

C877C878C879

C880

C881 C882C883

C884

C885

C886C887 C888

C889

C890

C891

C892 C893

C894

C895

FB813

FB814

FB815FB816

FB817

FB818

Q804

Q805

Q806

Q807

Q809

R882

R885

R886 R887 R888

R889 R890

R891

R892R893

R894

R895

R896

R897 R898R899

R900

R901

R902

R903

R904R906

R908

R910

R914

R915

R916

R917

R918

R919

R920

R921

R922R923

R924

R925

R926R927

R929

R930

R931

R932

R933

R934

R935

R936

R937

R938

R939

R940

R941 R942

R943

R944

R945

R946

R947

R948

R949

R881

R883

IC814

IC813

CN811

R848

R849

C872

Q808

R838

R928

Q802

Q803

R842

R884

R880

IC822(2/6)

JL853

C958

4725V

:AL-CP

HN1B01FU-TBUFF

HN1B01FU-TBUFF

HN1B01FU-TBUFF

HN1B01FU-TBUFF

HN1B01FU-TBUFF

1µH

0.125V

B:CHIP

0.4725V

F:CHIP

1µH

#

#

#

#

#

#

#

100:CHIP

100:CHIP

0:CHIP

0.125V

B:CHIP

4.7k:CHIP

0.125V

B:CHIP

100

:CHIP

100

:CHIP

100

:CHIP

100

:CHIP

0

:CHIP

100

:CHIP

100

:CHIP

100

:CHIP

#

100:CHIP

100:CHIP

100:CHIP

CXA2112RLCD DRIVER

0.125V

B:CHIP

#

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP#

#

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

#

0.125V

B:CHIP

1000pB:CHIP

1000pB:CHIP

0.125V

B:CHIP

# # #

# ##

2.2k:CHIP

100:CHIP

2.2k:CHIP

10k:CHIP

10k:CHIP

2.2k:CHIP

100:CHIP

2.2k:CHIP #

#

2.2k:CHIP

100:CHIP

2.2k:CHIP

10pCH:CHIP

10:CHIP

10:CHIP

10:CHIP

10 :CHIP

10 :CHIP

10 :CHIP

47:CHIP

47:CHIP

#

#

0:CHIP

470:CHIP

470:CHIP

27k:RN-CP

0:CHIP

0:CHIP

2.2:CHIP

0:CHIP2.2

:CHIP

0:CHIP

2.2:CHIP

0:CHIP

2.2:CHIP

0:CHIP

2.2:CHIP

0:CHIP

2.2:CHIP

0.1

25V

B:CHIP

100

16V

:AL-CP

476.3V:AL-CP

0:CHIP

0:CHIP

MB88346BPFV-EF12CH DAC

4725V

:AL-CP

476.3V:AL-CP

#

820:CHIP

3k:RN-CP

24PWHT

HN1B01FU-TBUFF

MAX4066CEESW

BK2125HM601T

BK2125HM601T

BK2125HM601T

BK2125HM601TBK2125HM601T

BK2125HM601T

BK2125HM601T

0

:CHIP

#

4.7k

:CHIP

2SA1162BUFF

2SA1162BUFF

10k:CHIP

5.6k:CHIP

TC74VHCT04AFT

INVERTER

#

10

10V

F:CHIP

5V-2

15.5V

R-SID OUT

B-SID OUT

MCLK

MCLK

G-SID OUT

15.5V-2

B-SID IN

15.5V-3

G-SID IN

R-SID IN

15.5V-4

15.5V-2

TP

G-SID IN

TP

G-SID OUT

RB DIR

5V-2

DWN

G OUT

R VCOM

B VCOM

15.5V

5V-2

DAC

SDAT

DALD

5V-3

5V-3

15.5V

PRG

D-SCLK

3 4

24

23

22

21

20

19

18

17

16

15

14

13

12

11

10

9

8

7

6

5

4

3

2

1

VID1

VID2

VID3

ENB

HST

HCK1G

HCK2G

ENB

VCK

VST

PCG

VID1

VID2

VID3

VID4

VID5

VID6

VID4

VID5

VID6

FRP

DLY-CON

SCEN

SID-OUT

PRG

DWN

POS-CON2

POS-CON1

INV-CON

GINV

GND

PSIG

HVDD

MODE3

MODE2

MODE1

HST

HCK2

VSS

BLK

ENB

VST

PCG

DWN

VVDD

COM

HCK1

VCK

SIG4

SIG3

SIG5

SIG2

SIG6

SIG1

XRGT

GREEN

TO (1/5)

TO (4/5)

TO (3/5)

TO (3/5)

TO (2/5)FROM (2/5)

FROM (2/5)

FROM (2/5)

FROM (1/5)

TO (4/5)

TO (3/5)

TO (4/5)

TO (4/5)

TO (3/5)

FROM (4/5)

FROM (4/5)


C(3/5)

B-SS1697<08.>-C..-P3

(G)

SIG CEN

ISET

SID-OUT

SID-IN

SID-OFST

VCC

FRP

SH-IN

INV-OUT

VIDEO IN

VCOM OFST

NC

NC

NC

SH-OUT5

SH-OUT4

PGND

NC

NC

NC

NC

NC

PVCC

SH-OUT3

SH-OUT2

SH-OUT1

VCOM OUT

NC

NC

GND2

POS-CNT2

NEXT-OUT

NEXT-IN

GND

S-12-CNT

ENB

DIR-CNT

NC

NC

NC

NC

NC

NC

NC

SH-OUT6

DGND

CLK-IN

PRG

CLK-IN

NC

NC

NC

NC

DLY-CNT

MCLK

INV-CNT

VDD

CLK-OUT

MCLK

CLK-OUT

OFFSET

POS-CNT1

F/R-CNT

VSS

A03

A04

A05

A06

A07

A08

A09

A010

VDD

GND

DI

CLK

LD

D0

A012

A011

VCC

SCEN

SH2

TO (2/5)

TO (2/5),(4/5)

TO LCD PANEL(G)


8-18 8-18

A B C D E F G H

1

2

3

4

5

VPL-CS1

C (4/5) C (4/5)

0

+15.5V

11

9

+15.5V

+15.5V+15.5V

+5V

10

0

0

4.8

3.7

3.7

3.4

3.4

3.4

3.4

0.4

5.0

4.1

5.0

4.4

5.0

7.0

7.0

7.0

7.0

7.0

7.0

3.3

2.2

7.0

7.0

2.5

3.3

2.4

1.3

6.9

2.0

6.5

0

0

4.8

3.7

3.7

3.4

3.4

3.4

3.4

0.4

5.0

4.1

5.0

4.4

5.0

7.0

7.0

7.0

7.0

7.0

7.0

3.3

2.2

7.0

7.0

2.5

3.3

2.4

1.3

6.9

6.5

2.2

6.9

8

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33343536373839404142434445464748

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

64

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33343536373839404142434445464748

49

50

51

52

53

54

55

56

57

58

59

60

61

62

63

641

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

IC817IC818

JL858

JL859 JL860

JL861

JL862

JL863JL864

L808

L809

L810

L811

R952 R953

R954 R955

R956 R957

R958 R959

R960 R961

R962 R963 R964

R965

R966 R967

R968

R969

TP809TP810

TP811

TP812

C896 C897

C898C899

C900

C901C902C903

C904C905

C906

C907

C908

C909

C910C911

C913

C914

C915

C916C917

C918C919

C920

C921

C922C923 C925

C926

C928

C929

C930

C931

C932

C933

C934

FB819

FB820

FB821

FB822

FB823 FB824

R950 R951

CN812

CN813

R996

JL857

C959

R997

C960

R998

R999

C912

4725V

:AL-CP4725V

:AL-CP

10016V

:AL-CP

10016V

:AL-CP

1µH

1µH

0.125V

B:CHIP 0.125V

B:CHIP

0.4725V

F:CHIP

0.4725V

F:CHIP

1µH

1µH

#

#

#

#

#

#

#

CXA2112RLCD DRIVER

CXA2112RLCD DRIVER

0.125V

B:CHIP0.125V

B:CHIP

0.125V

B:CHIP

#0.125V

B:CHIP#

0.125V

B:CHIP

0.125V

B:CHIP

#

0.125V

B:CHIP

#0.1 25V B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP

0.125V

B:CHIP0.125V

B:CHIP

10k:CHIP

10k:CHIP

10k:CHIP

10k:CHIP

10pCH:CHIP10p

CH:CHIP

10 :CHIP 10 :CHIP

10 :CHIP 10 :CHIP

10 :CHIP 10 :CHIP

10 :CHIP 10 :CHIP

10 :CHIP 10 :CHIP

10 :CHIP 10 :CHIP

#

#

#

#

27k:RN-CP

27k:RN-CP

0:CHIP

0:CHIP

0.1

25V

B:CHIP

0.1

25V

B:CHIP

4725V

:AL-CP

4725V

:AL-CP

476.3V

:AL-CP47

6.3V:AL-CP

820:RN-CP

#3k :RN-CP

820

:RN-CP

3k :RN-CP

24PWHT

24PWHT

10 10V F:CHIP 10 10V F:CHIP

0.1

25V

B:CHIP

BK2125HM601T

BK2125HM601T

BK2125HM601T

BK2125HM601T

BK2125HM601T BK2125HM601T

5V-2

15.5V

MCLK

MCLK

B OUT

5V-2

15.5V

MCLK

MCLK

R OUT

RB DIR

15.5V-3 15.5V-4

B-SID IN

R-SID IN

TP

TP

B-SID OUT

R-SID OUT

5V-2

TP TP

5V-2

B VCOM

DAC

RB DIR

R VCOM

DAC

24

23

22

21

20

19

18

17

16

15

14

13

12

11

10

9

8

7

6

5

4

3

2

1

24

23

22

21

20

19

18

17

16

15

14

13

12

11

10

9

8

7

6

5

4

3

2

1

VID1

VID2

VID3

VID4

VID5

VID6

ENB

SID-OUT

DLY-CON

POS-CON1

POS-CON2

VID1

VID2

VID3

VID4

VID5

VID6

ENB

SID-OUT

DLY-CON

POS-CON1

POS-CON2

HST

HCK1B

HCK2B

ENB

VCK

VST

PCG

HST

HCK2R

HCK1R

ENB

VCK

VST

PCG

VID1

VID2

VID3

VID4

VID5

VID6

FRP

VID1

VID2

VID3

VID4

VID5

VID6

FRP

SCEN

INV-CON

PRG

INV-CON

PRG

DWN

DWN

SCEN

RINVBINV

PSIG

HVDD

MODE3

MODE2

MODE1

HST

HCK2

VSS

BLK

ENB

VST

PCG

DWN

VVDD

COM

HCK1

VCK

SIG4

SIG3

SIG5

SIG2

SIG6

SIG1

PSIG

HVDD

MODE3

MODE2

MODE1

HST

HCK2

VSS

BLK

ENB

VST

PCG

DWN

VVDD

COM

HCK1

VCK

SIG4

SIG3

SIG5

SIG2

SIG6

SIG1

RGT

RGT

BLUE

RED

FROM (3/5)

TO LCD PANEL(R)

FROM (2/5)

TO (3/5)

TO (3/5)

TO (2/5)

FROM (3/5)

FROM (3/5)

FROM (1/5)

FROM (2/5)

FROM (3/5)

TO LCD PANEL(B)

FROM (2/5)

TO (3/5)

FROM (3/5)

FROM (3/5)

FROM (2/5)

FROM (2/5)

FROM (1/5)

FROM (3/5)


B-SS1697<08.>-C..-P4

C(4/5)

POS-CNT1

POS-CNT2

NEXT-OUT

NEXT-IN

F/R-CNT

GND

S-12-CNT

ENB

DIR-CNT SH-OUT6

SH-OUT5

SH-OUT4

PGND

PVCC

SH-OUT3

SH-OUT2

SH-OUT1

SIG CEN

ISET

SID-OUT

SID-IN

SID-OFST

VCC

FRP

SH-IN

INV-OUT

VIDEO IN

DLY-CNT

MCLK

INV-CNT

VDD

CLK-OUT

DGND

CLK-IN

PRG

MCLK

CLK-OUT

CLK-IN

OFFSET

VCOM OFST

VCOM OUT

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

GND2

(R)

POS-CNT1

POS-CNT2

NEXT-OUT

NEXT-IN

F/R-CNT

GND

S-12-CNT

ENB

DIR-CNT SH-OUT6

SH-OUT5

SH-OUT4

PGND

PVCC

SH-OUT3

SH-OUT2

SH-OUT1

SIG CEN

ISET

SID-OUT

SID-IN

SID-OFST

VCC

FRP

SH-IN

INV-OUT

VIDEO IN

DLY-CNT

MCLK

INV-CNT

VDD

CLK-OUT

DGND

CLK-IN

PRG

MCLK

CLK-OUT

CLK-IN

OFFSET

VCOM OFST

VCOM OUT

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

NC

GND2

(B)


8-19 8-19

A B C D E F G H

1

2

3

4

5

VPL-CS1

C (5/5) C (5/5)

0

7.6

7.6

7.5

0.5

0

0 7.6

3.50.5

0

0

0

0

0

0.5

3.5

7.6

0 0

5.9

6.0

5.9

5.9

5.9

5.9

5.9

5.9

5.9

4.0

2.5

5.9

5.9

5.9

5.9

1 2 3 4 5 6 7 8 9 10

11121314151617181920

12

345

67

8

12

345

67

8

1 2 3 4

R974

L812

L813

JL865

JL866

JL867

JL868

R971

R972

R975R977

R978

R979

R986R987

R988

R989 R990 R991

R992

R993

R994

R995

C936

C938C939

C940

C943

C945C947

C948

C949

C950

C951

C952

C953

C955

IC820

R980

R981R984

R985

R982

R983

R973

R976

C944

C935

C927

CN814

C937

C941

C954

C946

JL873

JL874

C942

Q811

Q810

IC819

Q813

Q812

IC821

0:CHIP 10

20V:TA-CP

0.01B:CHIP

1020V

:TA-CP

0.2225V

B:CHIP

0.2225V

B:CHIP

1:CHIP

1:CHIP

0.01B:CHIP

#

0:CHIP

100:CHIP

100:CHIP

0.125V

B:CHIP

100:CHIP

#

1016V

:AL-CP

1.5k:CHIP

100k:CHIP

3.3k:CHIP

10k:CHIP

1016V

:AL-CP

0.125V

B:CHIP

10016V

:AL-CP

2.2µH

4.7µH

#

#

#

#

0:CHIP

0:CHIP

47k:CHIP

47k:CHIP

110V

B:CHIP

110V

B:CHIP

2.2k

:CHIP

2.2k

:CHIP

8.2k

:CHIP

8.2k

:CHIP

0.1

25V

B:CHIP

2.220V:TA

5.6k:CHIP

5.6k:CHIP

220:CHIP

220:CHIP

2.220V:TA

0.047B:CHIP

22010

:AL-CP

22010V

:AL-CP

4PRED:SMD

#

#

0.047B:CHIP

0.01B:CHIP

4716V

:AL-CP

CXA1846BN-T4VOLUME

2SC2712MUTE

2SA1162MUTE

NJM062MAUDIO AMP

DTC144EKASW

DTC144EKASW

NJM062MAUDIO AMP

A-L

A-R

APCE

SDAT

AUDIO-MUTE

AUDIO +B

12V AUDIO GND

AUDIO-MUTE

A-SCLK

SDAT

APCE

APCE

SDAT

A-SCLK

A-SCLK

IN-R

GND

IN-L L-OUT

VS

R-OUT

LF.B.

RF.B.

SP-R

SP-L

AUDIO GND

AUDIO GND

IN-R

GND

IN-L L-OUT

VS

R-OUT

LF.B.

RF.B.

SPEAKER

FROM (1/5)

FROM (1/5)

FROM (1/5)

FROM (1/5)


B-SS1697<08.>-C..-P5

C(5/5)


8-20 8-20

A B C D E F G H

1

2

3

4

5

VPL-CS1

C C

C Board Waveforms

1 2 3 4

5 6 7 8

9 0 !-

1.4 Vp-p TP805 [R]

1.4 Vp-p TP804 [G]

1.3 Vp-p TP803 [B]

3.3 Vp-p TP813 [VD]

3.1 Vp-p TP814 [HD]

10.3 Vp-p TP806 [GINV]

10.3 Vp-p TP808 [G-VID|OUT]

10.3 Vp-p TP810 [BINV]

10.3 Vp-p TP809 [RINV]

10.3 Vp-p TP811 [B-VID|OUT]

10.3 Vp-p TP812 [R-VID|OUT]

CXA1846AN (IC820)

20 19 18 17 16 15 14 13 12 11

1 2 3 4 5 6 7 8 9 10

1dB STEP VOLUME

8dB STEP VOLUME

1dB STEP VOLUME

8dB STEP VOLUME

VCT BUFFERLATCH

SHIFT REGISTER

LATCH CONTROL

ZC DET

+–

+–

INP

1

INN

1

VCT

1

INAO

1

VRIN

1

OU

T 1

N.C

.

GN

D

VCT

VCC

INP

2

INN

2

VCT

2

INAO

2

VRIN

2

OU

T 2 CE

DAT

A

CLK

INIT

CXA2112R-T6 (IC815, 817, 818)

DLY CNT 49

MCLK 50

MCLK/ 51

INV CNT 52

VDD 53

CLK OUT CLK OUT/

D.P

D.P

DGND

CLK IN

NC

CLK IN/

SH

IN

FR

P

Vcc

SID

OF

ST

D.P

D.P

SID

IN

SID

OU

T

ISE

T

NC

SIG

CE

N

VC

OM

OF

ST

VC

OM

OU

T

54

55

56

57

58

59

60

61

GND2

SH OUT1

NC

SH OUT2

NC

PVccD.P

SH OUT3

D.PPGND

NC

SH OUT4

NC

SH OUT5

62PRG

NC

NC

63

64

32

31

30

29

28

27

26

25

24

23

2221

20

NC

SH OUT6

19

18

17

PO

S C

NT

1

PO

S C

NT

2

NE

XT

OU

TN

EX

T IN

F/R

CN

TG

ND

NC

D.P

D.P

S/1

2 C

NT

NC

EN

B

DIR

CN

T

45 44

VID

EO

IN

INV

OU

T

47

OF

FS

ET

48 46 43 42 41 40 39 38 37 36 35 34 33

1 2 3 4 5 6 7 8 9 10 11 12 13

NC

NC

NC

14 15 16

S/H

SID BIAS

S/H S/H BUFFER

INVERT AMP

BUFFER

BUFFER

BUFFER

BUFFER

BUFFER

S/H S/H

OFFSET CANCEL

OFFSET CANCEL

OFFSET CANCEL

OFFSET CANCEL

OFFSET CANCEL

OFFSET CANCEL

S/H

S/H S/H S/H

S/H

S/H PULSES

CLOCK DELAY

TIMING GENERATOR

S/H S/H

S/H S/H S/H

S/H S/H S/H

OFFSET CANCEL MODE TIMING

VCOM

D

MB88346BPFV-EF (IC813)

8 BIT LATCH

8 BIT R-2R

D/A CONVERTER

12 BIT SHIFT REGISTER

D0 D1 D2 D3 D4 D5 D6 D7 D8 D9 D10 D11

ADDRESS DECODER

1 2 3 4 12

D0 D7

8 BIT LATCH

8 BIT R-2R

D/A CONVERTER

D0 D7

1

2

3

4

5

6

7

8

9

10

1

20

19

18

17

16

15

14

13

12

11

A01 A12

812

GND

A02

A01

DI

CLK

LD

DO

A12

A11

VCC

VSS

A03

A04

A06

A07

A08

A09

A10

VDD

A05

M52749FP-TP (IC803)

Retrace BlankingMain BrightnessVCC=12V

CLAMPSUB

CONTRASTMAIN

CONTRASTOSD MIX AMP RETRACE

BLANKING

B SUB CONT 8bitG SUB CONT 8bitR SUB CONT 8bit

R OUTPUT

R OSD IN

R VCC 12V

R INPUT

CLAMP F/B

CLAMPSUB

CONTRASTMAIN


BLANKING G OUTPUT

G OSD IN

G VCC 12V

G INPUT

CLAMP F/B

CLAMPSUB

CONTRASTMAIN


BLANKING R OUTPUT

Contrast ref.

Contrast cont.

B OSD IN

B VCC 12V

B INPUT

CLAMP F/B

Sync On Green Sep DAC

BUS I/F

VCC 5V (DIGITAL)

Contrast(ABL) IN

SOG Sep OUT

SOG INPUT SDA

SCL

DAC output for cut-off Adj

OSD Blanking

Main CONTRAST

8bit

OSD LEVEL

4bit

Clamp Pulse IN

GND

GNDGNDGNDGND

GND

GND

GND

17

16

12

11

13

10

8

6

9

5

3

2

4

7

21 14 1 25 26 27 28 29 32 36 39

24

22

23

19

31

35

33

38

41

303442

20

8-21 8-21

A B C D E F G H

1

2

3

4

5

VPL-CS1

H H

5.0

-1.4

1

2

3

4

5

6

7

8

9

10

11

12

C001

R001

R002

R003

R004 R005 R006 R007 R008 R009 R010 R011

R012

R013 R014 R015 R016

S002 S003 S004 S005 S006 S007 S008

S009 S010 S011 S012

D001

D002D003

D004 D005 D006 D007

D008

D009 D010 D011 D012

Q001

CN001

JL002

JL003

JL004

JL005

JL006

JL007

JL008

JL009

JL010

S001

JL001

SEC1901CTEMP-LED

SEC1901CLAMP-LED

12P:SMD

SEC1801CPOWER-SAVE

DAP202KPROTECT

DAP202KPROTECT

DAP202KPROTECT

DAP202KPROTECT

DAN202KPROTECT

DAN202KPROTECT

DAN202KPROTECT

DAN202KPROTECT

DTA144EKASW

330

:CHIP

27k:CHIP

12k:CHIP

6.8k:CHIP

3.9k:CHIP

2.7k:CHIP

2.2k:CHIP

1.5k:CHIP

1.8k:CHIP

10k:CHIP

2.7k:CHIP

2.2k:CHIP

1.5k:CHIP

1.8k:CHIP

10k:CHIP

1k:CHIP

SEC2422CPOWER/STBY

0.125V

B:CHIP

#

#

#

#

#

#

#

#

#

#

RESET

GND

GND

LIGHT

D.5V

PSAVE-LED

POWER-LED

TEMP-LED

LANP-LED

SUB 5V

KEY1

KEY0

LEFT RIGHT DOWN UP ENTER MENU INPUT POWER

VOL-VOL+

SIRCS NR

APA

TO C BOARD CN5020

B-SS1697<08.>-H..

(CONTROL PANEL)H

H – B SIDE –SUFFIX ; -11

H – A SIDE –SUFFIX ; -11

8-22 8-22

A B C D E F G H

1

2

3

4

5

VPL-CS1

GA GA

G F E D C B A

1

2

3

4

A B C D E F G

1

2

3

4

——GA——1-675-795-11

D601 G-1D602 D-1D603 ∗ E-1D604 ∗ E-1D605 E-1D606 C-3D607 C-3D608 C-3D609 B-3D610 C-2D611 C-3D612 ∗ C-2D613 C-2D614 C-3D615 D-3D616 D-3D617 D-3D618 C-3D619 ∗ D-3D620 C-3D621 ∗ D-3D622 ∗ B-2

IC602 ∗ A-4IC603 C-2IC603 ∗ C-2IC604 D-3IC604 ∗ D-3IC605 ∗ F-1IC671 ∗ A-3IC671 ∗ A-4IC672 ∗ A-3

Q601 E-1Q601 ∗ E-1Q602 E-3Q602 ∗ F-3Q603 ∗ C-3Q604 ∗ G-1

VD602 E-3VD604 G-1

*:B Side mount

GA – B SIDE –SUFFIX ; -11

GA – A SIDE –SUFFIX ; -11

8-23 8-23

A B C D E F G H

1

2

3

4

5

VPL-CS1

GA GA• Refer to page 8-22 for Printed Wiring Board

+5V

+6V

1

2

4

3

1

2

4

3

2

3

4

5

6 7

8

9

10

11

12

1

2

4

3

1

2

3

4

5

6

7

8

9

1

2

3

41

1

1

S

DS

C

DS

C

1

2

3

1 234

12

34 5

67

8

12345678

9 10 11 12 13 14 15 16

1

2

3

4

5

6

7

8

9

10

12

34 5

67

8

1

2

3

4

5

6

I OG

C606

C609

C611

C612

C615

C616

C618

C620

C621

C622C623

C624

R601

R602

R603

R604

R609

R611

R613R615

R617

R620

R621R625

R626

R627

R631

R632

Q601D601D602

D603

D605

D608

D615

D616

D617

D621

IC603

IC604

CN601

L603

PH601

PH602

PH603

PS601

T601

VD602

VD604

C625C626

C627

C628

C631

C632

C633

C634

R622R623

R628

R634R635

R636

R637

R638

R640R641

R642

R644

R645R646

R647

R648

R649

R650 R651

R652 R653

D610

R618

R643

R639

R654C635

C604

CN606

R674

R679

R676

R671R677

R678

R672

C673

CN605

D609

R673

R606

C671 R675

C675

R610

R608

CN602

CN608

CN607

D612

D619

C672

C636

C638

C637

L601

C602

D604

D606

R605

R633

C617

C619

R629

R630

D607

D613

D611

D618

D620

D614

C629

R607

C674C608

D622

IC672FH601

CN604

C610

FH602

IC602

L602L604

Q602

F601

Q603

Q604

IC605

C601

C603

T602

Q671

IC671

12:CHIP

15k:CHIP

FSF10A60600V,10A

PC123FY2

22025V

100:CHIP

PC123FY2

FMG-G2CS1000V,3A

12k:CHIP

39k:CHIP

D6SB80800V,6A

2SK3013F

600V 16A

4.7:FPRD

6.8:CHIP

6.8:CHIP

1k:CHIP

4.7

:FPRD

3P:VH-B

0.1

B:CHIP

0.1

B:CHIP

0.1

B:CHIP

0.1

B:CHIP

270010V

FCQ20A06

FCQ20A06

TOP222Y-BBPWM CONTROL

TOP223Y-BBPWM CONTROL

47025V

ZP2600600V

#

PC123FY2

2A

47

16V

100p1kV

RGP10J600V,1A

68µH

2.2k

:RN-CP

0.1516V

B:CHIP68p

CH:CHIP

470pCH:CHIP

330pB:CHIP

0.1516V

B:CHIP

120

:RN-CP

100:CHIP

39k:CHIP

4.7k:CHIP

12k:CHIP

1000pB:CHIP

0.1F:CHIP

15

:CHIP

33k

:RN-CP

10k:CHIP

150k

:CHIP

33k

:CHIP1.5k

:RN-CP

0.1B:CHIP

1.5k

:CHIP

#

#

TF861S

270k1/2W:CHIP

270k1/2W:CHIP

270k1/2W:CHIP

180k1/2W:CHIP

180k1/2W:CHIP

220k1/2W:CHIP

180k1/2W:CHIP

RGP10G

560k1/2W

3901/2W:CHIP

6.8k:RN-CP

220:CHIP

1k:CHIP

ERZV14D471

5.65W

1801/2W:CHIP

4.7k

:RN-CP

2.2k:RN-CP

4.7k:CHIP

0.01:CHIP

10P

270k1/2W:CHIP

180

1/2W

:CHIP

4.7k

:RN-CP

6.8k

:RN-CP

33k

:CHIP

15k

:CHIP

0.1

B:CHIP

390

1/2W

:CHIP

D10SC9M

10:RN-CP

68k:CHIP

470

1/2W

:FPRD

0.01 :CHIP 47k :CHIP

#

4PWHT

D1FS4A-TA

D1FL20U-TA

SRT

68k

2W

10k

1/4W

:FPRD

#

#

#

RD8.2M-T1B1

RD8.2M-T1B1

2.2

450V

SS28V-25045

3A

D1FS4A-TA

0.22

5W

:RW

220

:CHIP

47

25V

0.022

400V

47k

3W

:RS

47k

3W

:RS

P6KE200A

P6KE350A

P6KE350A

P6KE350A

P6KE350A

P6KE300A

47

25V

47

16V

10

RD24M

100k:CHIP

220450V

RD20ES-T1B2

BA05FP-E2

0.22275V:MPS

10

0.47275V:MPS

10

6PWHT

0.033

630V

TL431BCDR2SHUNT REGULATOR

0µH 5A68µH

2SD2144S-TP-VINVERTER

250V

6.3A

2SC2712MAIN CONV ON/OFF

2SC2712ACT FILT ON/OFF

FA5331M-TE1PFC

0.0022

:E

2200p

:E

SRT

2SC2712INVERTER

TL431BCDR2SHUNT REGULATOR

AC(N)

AC(L)

GND 2

POWER CONT

GND 2

GND 2

N.C

T-OUT12

T-OUT11

GND 2

T-OUT12

DC W

GND 1 B

IDETCTSYNCREF

ON

OFFCSVCCVC

IFBVDET IINOVPVFBVINGNDOUT

GND 2

GND 2

18V

FAN PROT

GND

SUB+5

SUB+5

GND2

GND2

6V

6V

18V

GND

TO GBA BOARD CN671

TO GBB BOARD CN702

TO QA BOARD CN101

K

A

REF

A

A A

K

A

REF

A

A A

AC IN

100V-120V

220V-240V

50/60Hz

ACTIVE FILTER,CONTROL ACTIVE FILTERMAIN CONVERTER,SUB CONVERTER

GA

B-SS1697<08.>-GA.

FA5331M-TE1 (IC605)

1514 11 13 10 12

4

9

8

16 1

CT

5V

15K

CURR AMPPWM COMP

15K

OCP

V???

10K

ER.AMP

IDET IFB I IN- VDET

Vp

Vr

OVP

CS REF VCC NC

OVP

5 VFB

6 VIN

YC

OUT

7 GND

SYNC

Dmax

2 3

OSC BIAS BIAS

ON/OFF

10µA

RSS

Q

MUL

UVLO

CAUTION: For continued protection against risk offire, replace only with same type andrating of fuse.

8-24 8-24

A B C D E F G H

1

2

3

4

5

VPL-CS1

GBA, GBB GBA, GBB

+18V

1

2

3

1

2

3

1

2

3

4

5

6

GI O

ADJON/OFF

12

34 5

67

8

1

2

3

4

5

C677

C680

C681

C682

D672

D673

C683

R680 R681

R682

R683

R686

R687

R688

R697

R699

D674

D675 R700

R701

R721

C678

L671

R719

CN674

R717R716

R718

R720

C718

C684

C676

C679

C719

R689 R694

R698

R696

CN675

CN676

CN671

Q672

Q673

IC704

IC673

100:CHIP

100

:CHIP

1k:CHIP

DAN202K-T-146

0.1B:CHIP

0.1

B:CHIP

270

25V

0.1

B:CHIP

10k:CHIP

47k:CHIP

12k:CHIP

10k:CHIP

0.1B:CHIP

82k:RN-CP

68k:RN-CP

D1FS4A-TA

D1FS4A-TA

D1FS4A-TA0

:CHIP

4.7k

:RN-CP

10k

:RN-CP

0.1B:CHIP

10µH

5P

WHT

5.6k

:RN-CP

5.6k

:RN-CP

1k

:RN-CP

10k

:RN-CP

0.1

B:CHIP

47

16V

100

16V

3325V

1k:RN-CP

22k

:CHIP

22k

:CHIP

2235V

18k

:RN-CP

27k

:RN-CP

3PWHT

3PBLK

6PWHT

2SC2712FAN PROTECT

2SC2712FAN PROTECT

PQ20VZ1UFAN +B2 REG

LT1374IS8#TRDC-DC CONVERTER

POWER CONT

FAN PROT

VIN

BST

GND

VSW

VC

BIAS

GND 2

GND 2

POWER CONT

FAN PROT

FAN PROT

GND 2

GND 2

FAN+B

FAN+B

GND 2

FAN CONT2

FAN CONT1

18V

GND 2

FAN PROT

FB

FAN1

FAN2

TO GA BOARD CN604

TO C BOARD CN807

FAN DRIVEDC-DC CONVERTER

B-SS1697<08.>-GBA

GBA

GI O

ADJON/OFF

1

2

3

4

5

6

7

8

1

2

3

4

5

6

7

8

9

10

1

2

3

4

5

6

7

8

9

R708

R782

R707

R706

L707

C701

D715

R776 C772C769R775

C742

R781

C740

CN707

CN706

D728

L702

C702

C776

D727

C777

L703

C778

R785 R787 R788 R789

R784

D736

CN702

Q710

IC701

#

10k

:RN-CP

15k

:RN-CP

1.2k

:RN-CP

10µH

0.1

B:CHIP

D10SC9M

# ###

6.8k

:RN-CP

330

35V

D2FS6-TA

8PWHT

9PWHT

47025V

100µH

33

25V

47

16V

D2FS6-TA

47

16V

150µH

1.2k

1/2W

:CHIP

1.2k

1/2W

:CHIP

1.2k

1/2W

:CHIP

1.2k

1/2W

:CHIP

82

1/2W

:CHIP

10016V

RD13ES-T1TB2

10P

2SC2873YSOFT START

PQ20VZ1U16.5V REG.

AUDIO+B

AUDIO+B

GND 2

GND 2

GND 2

GND 2

GND 2

+16.5V

+16.5V

+6V

+6V

GND 2

GND 2

AUDIO GND

AUDIO GND

16.5V

AUDIO+B

GND 2

GND 2

T-OUT11

T-OUT12

GND 2

T-OUT12

GND 2

6V

6V

18V

TO C BOARD CN802

TO QA BOARD CN102

TO GA BOARD CN606

B-SS1697<08.>-GBB

(DC/DC CONVERTER)GBB

GBB – B SIDE –SUFFIX ; -11

GBB – A SIDE –SUFFIX ; -11

GBA – B SIDE –

SUFFIX ; -11

GBA – A SIDE –SUFFIX ; -11

The material contained in this manual consists ofinformation that is the property of Sony Corporation.Sony Corporation expressly prohibits the duplication ofany portion of this manual or the use thereof for anypurpose other than the operation or maintenance of theequipment described in this manual without the expresswritten permission of Sony Corporation.

Le matériel contenu dans ce manuel consiste eninformations qui sont la propriété de Sony Corporation.Sony Corporation interdit formellement la copie dequelque partie que ce soit de ce manuel ou son emploipour tout autre but que des opérations ou entretiens del’équipement à moins d’une permission écrite de SonyCorporation.

Das in dieser Anleitung enthaltene Material besteht ausInformationen, die Eigentum der Sony Corporation sind.Die Sony Corporation untersagt ausdrücklich dieVervielfältigung jeglicher Teile dieser Anleitung oder denGebrauch derselben für irgendeinen anderen Zweck alsdie Bedienung oder Wartung der in dieser Anleitungbeschriebenen Ausrüstung ohne ausdrücklicheschriftliche Erlaubnis der Sony Corporation.

Sony CorporationB & P Company

English

99KZ08111-1

Printed in Japan

©1999.119-929-671-01

Documents

Sony Vpl Cs1