Sony Compact Data Sheet

– 1 –

SERVICE MANUAL AEP ModelUK Model

PMC-R30L

PERSONAL COMPONENT SYSTEM

CD player sectionSystem

Compact disc digital audio systemLaser diode properties

Material: GaAlAsWave length: 780 nmEmission duration: ContinuousLaser output: Less than 44.6 µW(This output is the value measured at a distance ofabout 200 mm from the objective lens surface onthe optical pick-up block with 7 mm aperture.)

Spindle speed200 r/min (rpm) to 500 r/min (rpm) (CLV)

Number of channels2

Frequency response20 - 20,000 Hz +1/–2 dB

Wow and flutterBelow measurable limit

Radio sectionFrequency range

FM 87.5 - 108 MHz

MW 531 - 1,602 kHz

LW 153 - 279 kHz

IFFM: 10.7 MHzMW/LW: 450 kHz

AerialsFM: External aerial terminalMW/LW: External aerial terminal

– Continued on next page –

Cassette-corder sectionRecording system

4-track 2 channel stereoFast winding time

Approx. 120 s (sec.) with Sony cassette C-60Frequency response

TYPE I (normal): 70 - 10,000 Hz

GeneralSpeaker

Full range: 10 cm dia.,3 ohms, cone type (2)

OutputsHeadphones jack (stereo minijack)For 16 - 68 ohms impedance headphones

Maximum power output4.5 W + 4.5 W

Power requirementsFor personal component system:230 V AC, 50 HzFor remote control:3 V DC, 2 R6 (size AA) batteries

Power consumptionAC 23 W

CDModel Name Using Similar Mechanism PMC-107L

Section CD Mechanism Type KSM-213CDM

Optical Pick-up Name KSS-213C

TC Model Name Using Similar Mechanism PMC-107LSection Tape Transport Mechanism Type MF-107

SPECIFICATIONS

MICROFILM

Ver 1.0 1999. 07

– 2 –

SAFETY-RELATED COMPONENT WARNING!!

COMPONENTS IDENTIFIED BY MARK ! OR DOTTED LINEWITH MARK ! ON THE SCHEMATIC DIAGRAMS AND INTHE PARTS LIST ARE CRITICAL TO SAFE OPERATION.REPLACE THESE COMPONENTS WITH SONY PARTS WHOSEPART NUMBERS APPEAR AS SHOWN IN THIS MANUAL ORIN SUPPLEMENTS PUBLISHED BY SONY.

Dimensions (incl. projecting parts)Player: Approx. 160 × 249 × 227 mm (w/h/d)Speaker: Approx. 150 × 245 × 192 mm (w/h/d)

MassPlayer: Approx. 2.8 kgSpeaker: Approx. 1.2 kg

Supplied accessoriesRemote control RMT-C107AD (1)FM lead aerial (1)MW/LW loop aerial (1)

Design and specifications are subject to change withoutnotice.

TABLE OF CONTENTS

1. SERVICING NOTES ......................................................... 3

2. GENERALPlaying a CD ........................................................................... 4Listening to the radio ............................................................... 4Playing a tape .......................................................................... 5Recording on a tape ................................................................. 5

3. DISASSEMBLY3-1. Cabinet (Front) Assy ........................................................... 63-2. Cabinet (Upper) Assy .......................................................... 73-3. Power Board ........................................................................ 73-4. Main Board ......................................................................... 83-5. CD Board ............................................................................ 83-6. Optical Pick-up ................................................................... 93-7. Tape Mechanism Block ....................................................... 93-8. Control Board and Back Light Board ............................... 103-9. How to Apply the Belts ..................................................... 103-10. Head, Magnetic (HRP301) ................................................ 113-11. Motor Assy (M301) ........................................................... 11

4. MECHANICAL ADJUSTMENTS ............................... 12

5. ELECTRICAL ADJUSTMENTSTape Section .......................................................................... 12Tuner Section ......................................................................... 13CD Section ............................................................................ 14

6. DIAGRAMS6-1. IC Pin Description ............................................................. 156-2. Circuit Boards Location .................................................... 166-3. Block Diagram –CD Section– ........................................... 176-4. Block Diagram –Main Section– ........................................ 196-5. Printed Wiring Boards –CD Section– ............................... 216-6. Schematic Diagrams –CD Section– .................................. 236-7. Printed Wiring Boards –Control Section– ......................... 256-8. Schematic Diagrams –Control Section– ........................... 276-9. Printed Wiring Boards –Main Section– ............................ 296-10. Schematic Diagram –Main Section (1/2)– ........................ 316-11. Schematic Diagram –Main Section (2/2)– ........................ 336-12. Printed Wiring Board –Power Supply Section– ................ 356-13. Schematic Diagram –Power Supply Section– ................... 35

7. EXPLODED VIEWS7-1. Cabinet (Rear) Section ...................................................... 407-2. Cabinet (Front) Section ..................................................... 417-3. Cabinet (Upper) Section .................................................... 427-4. Tape Mechanism Section-1 ............................................... 437-5. Tape Mechanism Section-2 ............................................... 447-6. Tape Mechanism Section-3 ............................................... 457-7. Tape Mechanism Section-4 ............................................... 467-8. Optical Pick-up Section .................................................... 477-9. Speaker Section ................................................................. 48

8. ELECTRICAL PARTS LIST ......................................... 49

– 3 –

CAUTIONUse of controls or adjustments or performance of proceduresother than those specified herein may result in hazardous ra-diation exposure.

NOTES ON HANDLING THE OPTICAL PICK-UPBLOCK OR BASE UNIT

CHUCK PLATE JIG ON REPAIRING

On repairing CD section, playing a disc without the lid (CD), useChuck Plate Jig.• Code number of Chuck Plate Jig: X-4918-255-1

The laser diode in the optical pick-up block may suffer electrostaticbreakdown because of the potential difference generated by thecharged electrostatic load, etc. on clothing and the human body.During repair, pay attention to electrostatic breakdown and also usethe procedure in the printed matter which is included in the repairparts.The flexible board is easily damaged and should be handled withcare.

NOTES ON LASER DIODE EMISSION CHECKThe laser beam on this model is concentrated so as to be focused onthe disc reflective surface by the objective lens in the optical pick-up block. Therefore, when checking the laser diode emission, ob-serve from more than 30 cm away from the objective lens.

This Compact Disc player is classified as aCLASS 1 LASER product.The CLASS 1 LASER PRODUCT table islocation on the rear exterior.

SECTION 1SERVICING NOTES

LASER DIODE AND FOCUS SEARCH OPERATIONCHECK1. Open the CD lid.2. Turn OPERATE switch on with to set the CD.3. Turn on SW701 as following figure.4. Press the (CD) button.5. Confirm the laser diode emission while observing the objecting

lens. When there is no emission, Auto Power Control circuit orOptical Pick-up is broken.Objective lens moves up and down three times for focus search.

Push on SW701 in thearrowed direction witha screwdriver, etc.

SW701

– 4 –

SECTION 2GENERAL This section is extracted

from instruction manual.

– 5 –

– 6 –

SECTION 3DISASSEMBLY

• The equipment can be removed using the following procedure.

Note : Follow the disassembly procedure in the numerical order given.

3-1. CABINET (FRONT) ASSY

Set Cabinet (Front) assy Cabinet (Upper) assyPower boardTape mechanism block

Control board and Back Light board

Main boardCD board Optical pick-up

How to apply the beltsHead, magnetic (HRP301)

Motor assy (M301)

3 BVTP 3x14

1 BVTP 3x142 BVTP 3x14

4 CNP303

6 CNP301

0 wire

9 CNP702

7 CNP302

5 CNP306

8 CNP308

!¡ cabinet (front) assy

– 7 –

3-2. CABINET (UPPER) ASSY

3-3. POWER BOARD

2 BVTP 3x10

3 BVTP 3x10

5 cabinet (upper) assy

1 BVTP 3x10

4 CNP901

2 BVTP 4x16

3 POWER board

1 CNP902

– 8 –

3-4. MAIN BOARD

3-5. CD BOARD

2 BVTP 3x10

1 CNP704 3 MAIN board

1 CNP701

2 CNP703

3 connector

5 BVTP 3x10

7 CD board

6 sheet, plastic

4 BVTP 3x10

– 9 –

3-6. OPTICAL PICK-UP

3-7. TAPE MECHANISM BLOCK

3 optical pick-up

2 screws (2.6x16)1 screws (2.6x16)

3 BVTP 3x10

2 BVTP 3x10

4 tape mechanism block

1 Open the cassette lid.

– 10 –

3-8. CONTROL BOARD AND BACK LIGHT BOARD

1 BVTP 3x10

6 BVTP 3x8 5 CNP801

7 BVTP 3x10

8 knob (SNOOZE)

9 BACK LIGHT board

2 BVTP 3x10

4 CONTROL board

3 CNP802

3-9. HOW TO APPLY THE BELTS

2 belt

1 belt

motor assy (M301)

FW assy

idler assy, PF

– 11 –

3-10. HEAD, MAGNETIC (HRP301)

3-11. MOTOR ASSY (M301)

2 screw

1 PTT 2x4

3 head, magnetic (HRP301)

1 spring

2 BVTT 2.6x5

4 PTT 2.6x6

holder, motor

5 motor assy (M301)

3 claw

– 12 –

phones jack (J302)

set

32 Ω

test tapeWS-48A(3 kHz, 0 dB)

digital frequencycounter

TAPE SECTION 0 dB = 0.775 V

• Standard Output Level

Output terminal HP OUT

load impedance 32 Ω

output signal level 0.25 V (–10 dB)

• Test Tape

Type Signal Used for

WS-48A 3 kHz, 0 dB tape speed adjustment

Tape Speed AdjustmentProcedure:Mode: playback

PRECAUTION1. Clean the following parts with a denatured-alcohol-moistened

swab :record/playback head pinch rollererase head rubber beltscapstan idlers

2. Demagnetize the record/playback head with a head demagne-tizer. (Do not bring the head magnetizer close to the erase head.)

3. Do not use a magnetized screwdriver for the adjustments.4. After the adjustments, apply suitable locking compound to the

parts adjusted.5. The adjustments should be performed with the rated power

supply voltage unless otherwise noted.

Torque Measurement

Mode Torque meter Meter reading

FWD CQ-102C 30 – 70 g • cm(0.42 – 0.97 oz • inch)

FWD CQ-102C 1.5 – 5.5 g • cmBack Tension (0.021 – 0.076 oz • inch)

FF CQ-201Bmore than 60 g • cm

(more than 0.83 oz • inch)

REW CQ-201B more than 60 g • cm(more than 0.83 oz • inch)

Tape Tension Measurement

Mode Tension meter Meter Reading

FWD CQ-403A more than 100 g(more than 3.53 oz)

SECTION 5ELECTRICAL ADJUSTMENTS

SECTION 4MECHANICAL ADJUSTMENTS

Adjust so that the value on the digital frequency counter is3,000 Hz.

Specification Value:Digital frequency counter

2,985 to 3,015 Hz

Adjust so that the frequency at the beginning and that at the end oftape winding are between 2,955 to 3,045 Hz.

Adjustment Location:

TAPE SPEEDAdjustment

– 13 –

FM FREQUENCY COVERAGECHECK

Frequency Display 87.5 MHz 108 MHz

Reading on Digital voltmeter 1.8 ± 0.2 V 5.6 ± 0.2 V

Adjustment Part <confirmation> <confirmation>

FM TRACKING CHECK

Adjust for a maximum reading on level meter.

<confirmation> <confirmation>

87.5 MHz 108 MHz

MW FREQUENCY COVERAGEADJUSTMENT

Frequency Display 531 kHz 1,611 kHz


Adjustment Part L5 CT4

MW TRACKING ADJUSTMENT


L3 CT2

621 kHz 1,404 kHz

AM IF ADJUSTMENT


CFT1

450 kHz

LW FREQUENCY COVERAGEADJUSTMENT

Frequency Display 153 kHz 279 kHz


Adjustment Part CT3 <confirmation>

LW TRACKING ADJUSTMENT


L4 CT1

162 kHz 261 kHz

Adjustment Location: MAIN board (See page 14.)

TUNER SECTION 0 dB = 1 µV

Precautions in RepairingNote : As a tuner unit (TU1) is difficult to repair if faulty,

replace it with new one.

• FM SectionSetting:BAND button: FM

22.5 kHz frequencydeviation by 400 Hz signaloutput level : as low as possible

• MW/LW SectionSetting:BAND button: MW or LW

30% amplitudemodulation by 400 Hz signaloutput level : as low as possible

• Connecting Level Meter (FM, MW and LW)

• Connecting Digital Voltmeter (FM, MW and LW)

• Repeat the procedures in each adjustment several times, and thefrequency coverage and tracking adjustments should be finallydone by the trimmer capacitors.

FM terminal (CNP2)

FM RF signalgenerator

0.01 µF

set

Put the lead-wireantenna close tothe suppliedMW/LW loop aerial.

AM RF signalgenerator

phones jack (J302)

set

32 Ω

level meter(range: 0.5-5 V ac)

digitalvoltmeter

tuner boardTP (VT)

– 14 –

C706

C711

C712

CNP701C723

C709R704

1

16

R701

R706

R721

R720

R725

R726

R715

R717

R740

JW70

5

JW70

3

JW71

3

152

1314

2627

3940 C7

05

C724

C717

C721

C715

C707

C737

C738

IC701

TP (RF)

– CD board (conduction side) –

Adjustment Location:

CD SECTION

CD section adjustments are done automatically in this set.In case of operation check, confirm that focus bias.

FOCUS BIAS CHECK1. Connect the oscilloscope between IC701 pin #£ (TP RF) and

GND on CD board.2. Set the Test Disc YEDS-18 (CD). (Part No. : 3-702-101-01)3. Press the (CD) button.4. Confirm that the oscilloscope waveform is as shown in the

figure below. (eye pattern)A good eye pattern means that the diamond shape ( ) in thecenter of the waveform can be clearly distinguished.

• RF signal reference waveform (eye pattern)

π

Test Point:

RF level :1.2 ± 0.1 Vp-p

VOLT/DIV : 200 mV (10 : 1 probe in use)TIME/DIV : 500 nS

When observing the eye pattern, set the oscilloscope for AC rangeand raise vertical sensitivity.

L4

CT1

LWTRACKING

ADJUSTMENT

CFT1AM IF

ADJUSTMENT

IC1

TU1

TP (VT) (conductor side)

CNP2

CT4

L5

MWFREQUENCYCOVERAGE

ADJUSTMENT

CT3LW

FREQUENCYCOVERAGE

ADJUSTMENT

L3

CT2

MWTRACKING

ADJUSTMENT

– MAIN board (component side) –

– 15 – – 16 –

6-2. CIRCUIT BOARDS LOCATION

Pin No. Pin Name I/O Pin Description

77 – 88 SEG20 – 31 O LCD segment signal output terminal

89 VDD — Power supply (+ 5V)

90 NC — Connected to VDD.

91 VSS — Ground

92 TX O Crystal connection for clock oscillation. (32.768 kHz)

93 TEX I Crystal connection for clock oscillation. (32.768 kHz)


99 REC I Tape REC detection signal input (from SW301)

100 PLAY I Tape PLAY detection signal input (from S302)

MAIN board

CD board

CD MOTOR board

POWER board

HEADPHONE board

REC SW board

KEY board

CONTROL board

BACK LIGHT board

6-1. IC PIN DESCRIPTION• IC801 CXP83232A-015Q (SYSTEM CONTROL)

Pin No. Pin Name I/O Pin Description

1 REG I AC check input

2 C-SCOR I CD-SCOR input

3 RMC I SIRCS receiver input

4, 5 NC — Not used.

6 C-SENS I CD SENS-1 input

7 C-SENS2 I CD SENS-2 input

8 RDS-CLK O Tuner demodulator clock output

9 RDS-DATA O Tuner demodulator data output

10 C-XRST O CD system reset output

11 C-SQCK O Clock output for CD SUB-Q.

12 C-SQSO I CD SUB-Q input

13 A-MUTE O Mute signal output for audio.

14 R-ST I Stereo detection input

15 R-COUNT I Tuner PLL IC count input

16 R-DATA O Tuner PLL IC data output

17 R-CLK O Tuner PLL IC clock output

18 R-CE O Tuner PLL IC chip enable output

19 V-CE O Electrical volume chip enable output

20 V-DAT O Volume data output

21 V-CLK O Volume clock output

22 C-CLK O Clock output for CD-DSP command.

23 C-XLAT O CD-DSP command latch output

24 C-DATA O CD-DSP command data output

25 PA-CON O Power on/off control output

26 REG-CON O Regulator on/off control output. LED (STANDBY) control signal output.

27 C-MUTE O Mute signal output for CD.

28 BACKLIGHT-ON O Not used.

29 RDS-IND O Not used.

30 – 32 KEY1 – 3 I Key return signal input

33 VER I Mode setting terminal

34 C-DOOR I CD lid open/close detection input

35 NC — Not used.

36 9/10K I Not used.

37 SHIFT-CLK O Shift clock on/off output

38 RST I Reset signal input

39 EXTAL I Clock oscillation input (8 MHz)

40 XTAL O Clock oscillation output (8 MHz)

41 VSS — Ground (for A/D converter)

42, 43 NC — Not used.

44 AVREF I Reference voltage input (for A/D convereter)

45 AVSS — Ground (for A/D converter)

46 VL O LCD bias resistor current control terminal (Cut off at standby)

47 – 49 VLC3 – 1 — LCD bias power supply terminal

50 – 53 COM0 – 3 O LCD common signal output terminal


74 RADIO O Regulator on/off control output for radio block.

75 TAPE O Regulator on/off control output for tape block.

76 CD O Regulator on/off control output for CD block.

SECTION 6DIAGRAMS

PMC-R30L

6-3. BLOCK DIAGRAM — CD SECTION —

– 17 – – 18 –

A 5CNP701

CNB703

7

6

4

10

12

3

8

1415

1316

C

B

E

F

D

LD

PD

LD ONSWITCH

Q701

LASERDIODE

CONTROL

PD1

PD2

LD

PD

E

F

VC

RF AMP

SERIAL/PARALLEL

CONVERTERDECODER

COMMAND

FE AMP

VREF

TTL

IILXRST

CLKXLT

DATA

SENS2SENS1C. OUT

FOK

RF O

IIL

TTL

42

41

51

13

36

39

37

23

202122

262524

33

27

38

RF AMP & SYSTEM SERVO PROCESSORIC701

TRACKINGPHASE

FOCUSPHASE

6 16

TAO

FEO

SLO

191718

TRACKINGCOIL

DRIVE

25

7

FOCUSCOIL

DRIVE

TIN

FIN

3SLED

MOTORDRIVE

SLIN

15SPINDLEMOTORDRIVE

SPI

MUTE

T+T–

2627

F+F–

21

SL+SL–

1211

SP+SP–

TRACKINGCOIL

FOCUSCOIL

OPTICAL PICK-UPBLOCK

(KSS-213C)

M

M

M702SLED

MOTOR

M701SPINDLEMOTOR

SLED/SPINDLEMOTOR DRIVE

TRACKING/FOCUSCOIL DRIVE

IC702

S701(LIMIT)

RF

FOK

CNINSEIN

DATOXLTOCLKO

XRST

SERVOAUTSEQ.

D/AINTERFACE

SUB CODEPROCESSOR

EFM DEMODULATOR

DIGITALCLV CPU INTERFACE

MDP

XLON

SENS

SQSO

SCOR

SPOA

SQCK

DATA

XLAT

CLOK

SYSM

XTAI

XTAO

SERIALINTERFACE

DIGITALFILTER

&D/A

CONVERTER

AOUT1

LOUT1

AOUT2

LOUT2

PWMAMP

PWMAMP

CD L-CH

R-CH

MAINSECTION

135

18

1110

121314

79

21 15 17 6 5 574 7 8 9 62 70•71

65

67

76

74

DIGITAL SIGNAL PROCESSOR, D/A CONVERTERIC703

10

74

34

67 12 11 24 23 22 272

X70116.9344MHz

XRST

SENS

2SE

NS1

SQSO

SQCK

SCOR

DATA

XLAT CLK

MUT

E

C-DOORCD

RADI

O

76

CD

SYSTEM CONTROLIC801 (1/2)

RADIO ONSWITCH

Q306

CD ONSWITCH

Q302,307

COM 5VRA5V

COM 5VCD5V

SW701(CD DOOR)

04

• Signal path : CD

R-ch : same as L-ch.

43

65

21

CNP705

12

CD BOARD

MAIN BOARD(1/2)

CONTROL BOARD (1/2)

3

CNP704

1

9CNP303

11

9CNP805

11

CNP806111098536712

4

CNP702123479651110

8

(Page 19)

6-4. BLOCK DIAGRAM — MAIN SECTION —

PMC-R30L

– 19 – – 20 –

M

5

4

21

6

24

99

100

18 17 16 15

40 39 37

14

50–53

15

75

1713 12 20 19 18

21 20 19 13

26

21

20 31 24 11

5

5

23

22

PBIN1

REC1

P/R

VREFVREF

RAIN

1

TAPE

CDIN1

CD L-CH

ALC AMP

SW301REC

PB -1

-2

CONTROL SEL

OUT1

PRE-AMPIC301

R-CH

R-CH

L-CH

HRP301RECORD/PLAYBACK

HEAD

1CD

SECTION

S302(MD PLAY)

S301(MD POWER)

PLAY

COM

0

REC

COM

3

54–73,77–88,94–98 92•93 30–32

SEG0

SEG3

6

R-CE

R-CL

K

R-DA

TA

R-CO

UNT

LCD801

SURROUND TONE VOL

CONTROL

PORT

2

PORT

1

CLK

DATA

BCLATC

H

VOLUME/SOUND CONTROLIC302

POWER AMPIC303

Q304 SP301SPEAKER

(L-CH)

R-CHR-CH

J302PHONES

V-CE

A-M

UTE

25

PA-C

ON

38

29

RST

RDS

IND

V-DA

TA

V-CL

K

TAPE

X80232.768kHz

X8018MHz

CLOCKSHIFTQ802

CLOCKSHIFTQ801

R-ST

KEY1

KEY3

3

IRRECEIVER

IC802

RMC

8

CLK

9

DATA

SHIF

T-CL

K

EXTA

L

XTAL

TEX

TX 1REG

REGCON

RESETIC804

REGQ309,310

LED DRIVEQ803

REGQ308

REGIC803

T901POWER

TRANSFORMER

SYSTEM CONTROLIC801 (2/2)

S801–803,807

S808–823,825,826 S805,806

RECTD901–904

SWITCHQ807

D905

AC IN

MUTECONTROL

Q305,311, 313

STBY

OUT2

VC

IN2

+8V

M301CAPSTAN /REEL

MOTOR

RA 5V

+5V

VREF

VREF

BIASOSCQ303

REC/PBSW

Q301, 312

RECPB

T301RECBIAS

Signal path: FM

: MW

: PB

: REC

: CD

R-ch : same as L-ch.

RDS

VDD 5V

S824RESET

8V

D806R•D•S

COM5V

VDD5V

REGQ314

CD6V

VCC

4

11

5 6 7

CE CK DA CD

CE CK DA CD

MW

10 LW

2117 16 1 2 8

13

13 1814 171920

2124

178

5

22

4 6

16 1511

12

10

2

PD1

FM IN

AM IN

XOUT XIN

IF IN

MO/

ST FM

X175kHz

9

IF R

EG

1514

AMOSC

FMOSC

AMMIX

FMMIX

AM IN IFBUFFER

MO/

ST

BAND

ST-IN

D

AMDET

7 FMDET

AFBUFFER

FMMPX MUTE

R-CH

QUAD

R

L

CF3CF2CF1

CFT1

Q9

LWSWITCH

Q5

LWSWITCH

Q4

LPFQ16

VTQ17

MW/LWSWITCH

Q2,3

L3, 4(MW/LW ANT)

CT1

CT2

AMPQ1

8V

D302

Q7

Q6

D3

RADIO 5V

L5CT3

CT4

FM/MW/LW FRONT-END, IF DET,FM STEREO DEMODULATOR

IC1

PLLIC2

Q15

Q20

Q8Q11 Q14

OSC

CNP2

MW/LW

FM

CNP1

POWERCONTROL

Q10,22

AMPQ18AM HI-CUT

Q13

TU8V 8V

POWERCONTROL

Q21RDS5V RA5V

L15

B-MUTE

ANTVT OSC OUT

IF OUTTU1

12

RDAT

ARD

ATA

16

RCLK

RCLK

4

MUX

13XI

14XO

X24.332MHz

RDS MODULATOR

IC3

CE CK DA CD

RDAT

A

RCLK

LED DRIVEQ805

D804OPERATE

CNP304

5

CNP301

4

3

2HE301ERASE HEAD

4

3

2

CNP302

12

43

CNP311

12

43

CNP306

6

5

4

2

1

6

5

4

3 32

1

3

8 10 4 14 13 12 15 19 22 18

23

16

2 15 6 7 17

REC SWBOARD POWER BOARD

CONTROL BOARD (2/2)KEYBOARD

BACK LIGHTBOARD

HEADPHONE BOARD

MAIN BOARD (2/2)

CNP303

3

8 10 4 14 13 12 15 19 22 182 15 6 7 17CNP805

2

3

23

16

CNP805

2CNP803

CNP804

2

53

4

CNP307

J301SPEAKER

2

53

4

CNP308

CNP303

CNP305

2

3

CNP901

2

3-5CNP802

1

3-5CNP801

1

04

CFT1AM IF

CT1,L4LW

TRACKING

CT2,L3MW

TRACKING

CT3LW

FREQUENCYCOVERAGE

CT4,L5MW

FREQUENCYCOVERAGE

(Page 18)

1

A

B

C

D

E

F

G

2 3 4 5 6 7 8 9 10 11 12 13 14

R703

R705

C702

C706

C711

C712

L704

CNP701C723

Q701

C709

C701

C722

C727

R724R756

R723

R702

R704

1

16

R701

R706

R710

R729

R721

R720

R752

R757

R738

R730

R734

R727

R725

R758 R7

28

R726

R715

R717

R719

R740

R744

R745

R746

R743

R759

R733

R732

R713

C760R742

R741CNP702

R755

R735CNP703

R748

R731R736

R754

C708

C714

C704

C710R747C749

C703JW732

JW739

JW726

JW725

JW721

JW740

JW714

JW706

JW707JW708

JW704

JW736

JW723

JW735

JW734JW731

JW712

JW702

JW70

5

JW70

3

JW71

3

JW738

JW70

1

JW72

9

JW71

8

JW72

0

JW71

9

JW71

7

JW72

2

JW71

6 JW71

5

JW71

1 JW71

0

JW72

7JW

728

JW73

7

JW72

4 JW73

0

JW733

1

152

1314

2627

3940

14

15 28

R714

R722

R716

C716

C705

C729

C724

C719

C717

C721

C715

C730

C731

C739

C740

C713

R718

R711

R737

R707

R709

R712

C707

CD BOARD

1 MAIN BOARDCNP304

SW701(CD DOOR)

2 CONTROL BOARDCNP806

OPTICAL PICK-UPUNIT

KSS-213C

04

C770

C732

C748

C718

C734

C725

C744

IC702

C753C756

C776

C769

C765

C720

C743

C766

C742

C737

C738

C759

C763

C767

C764

C733

C757

C778

C777

C758

C751

C774

IC703

IC701

C772C754

C782

R751X701

C752

C745

C741

C726

C779

C768

C728

R753

C761 R7

39

R750

R749

C762

C755

C750

C773

L701

L705

FB70

1

FB70

2

L703

C775

C783

L702

CNP705

CNP704

1-674-301- 11

16

1

2

1

11

1

7

CD MOTOR BOARD

1-658-023-

S701(LIMIT)

M701(SPINDLE)

CNP707

1BLKBLKBLKBLKBLKWHT

6

31(31)

MM702(SLED)

M

180

6160

4140

21

20

TP(RF)

PMC-R30L

– 21 – – 22 –

6-5. PRINTED WIRING BOARDS — CD SECTION — • Refer to page 16 for Circuit Boards Location.

Common note on Printed Wiring Boards:• X : parts extracted from the component side.• ¢ : internal component.• b : Pattern from the side which enables seeing.

IC701 E-6IC702 B-7IC703 D-4

Q701 F-4

• SemiconductorLocation

Ref. No. Location

(Page 30)

(Page 25)

Common note on Schematic Diagram:• All capacitors are in µF unless otherwise noted. pF: µµF

50 WV or less are not indicated except for electrolyticsand tantalums.

• All resistors are in Ω and 1/4 W or less unless otherwisespecified.

• ¢ : internal component.• C : panel designation.

• U : B+ Line.• Voltage is dc with respect to ground under no-signal

(detuned) condition.• Waveforms are dc with respect to ground in playback

mode.no mark : FM or CD( ) : MW< > : LW

∗ : Impossible to measure• Voltages are taken with a VOM (Input impedance 10 MΩ).

Voltage variations may be noted due to normal produc-tion tolerances.

• Waveforms are taken with a oscilloscope.Voltage variations may be noted due to normal produc-tion tolerances.

• Circled numbers refer to waveforms.• Signal path.F : FMf : MWE : PBa : RECJ : CD

Note: The components identified by mark ! or dotted linewith mark ! are critical for safety.Replace only with part number specified.

PMC-R30L

– 23 –

6-6. SCHEMATIC DIAGRAMS — CD SECTION — • Refer to page 36 for IC Block Diagrams.

– 24 –

Approx. 100mVp-p

IC701 $¶ (TEI)

• Waveforms (MODE:PLAY)

1

2

3

4

5

2.5V

1.2±0.1Vp-p

Approx. 200mVp-p

IC701 1 (FEO)

2.5V

IC703 @¡ (MDP)

2Vp-p

7.6µsec

16.9344MHz

IC703 &¡ (XTAO)

2.2Vp-p

IC701 #£ (RFO)

(Page 34) (Page 27)

1

A

B

C

D

E

F

G

H

I

2 3 4 5 6 7 8 9 10 11 12 13 14

KEY BOARD

BACK LIGHT BOARD

CONTROL BOARD

2 3 CD BOARD

CNP702MAIN BOARD

CNP303

04

S809STANDBY

1-674-300- 11

1-674-301- 11

1-674-303- 11

S805SNOOZE

S825SOUND

S817DSPL

ENT MEM

S822 S808

S814

CNP801

SLEEP

S816PLAY MODE•MONO/ST ISS

S815PRESET +

S813BAND

S823PRESET –

S818 S819 S820 S821

S810SUMMER

S811CLOCK

R•D•S

S812TIMER

S826FUNCTION

R820

R821

D806

R822

R826

R824

R823

R838

JW805

R819

R833

R827

R828

R829

R830

R831

R834R801

R835

R806

R818

R863

R847

R848

R849

R850

R816

R810

R809

R808

R846

R811

R845

R844

R804

R880

R872

R873

R805

R832

R840 R8

39

R874

R865

R875

R864

R836

R860

R843

R837

R842

R841

R862

R858

R857 R8

56

R859

R855

R854

R881

R861

R812

R813

R815R814 R869

R876

R866R877

R868

R878

IC803

R817R867

CNP802

R853

R851

R852

C820

C821C823

C813

C829

C831

C830

C810

C832

JW824

JW842

JW838JW845

JW835JW822

JW816

JW826

JW841

JW82

3

JW82

0

JW80

1

D801

JW83

9

JW82

1

JW82

5

JW81

0

JW84

4

L801

D802

JW83

6

JW83

7

JW81

3

JW83

4

JW83

3JW843

JW815

JW804

JW846

JW808

JW2

JW807JW831

C802

Q801

Q802

Q805

Q803

C809X801

C806

C805

C801

C804

C814

CNP805

CNP806

C811

IC802

C822

X802

C835 L804

C824

C828

C838

C815

C816

C817

C818

C825

C833

C826

C808

C803

R807

C836

C837

C807

C827

R870

R871

IC801

R825S802

S803

R879

JW806

JW803JW802

JW840

R883

R882

R803

R802

S807OPERATE

CNP804

CNP803

D805

Q807

D804

D803

LCD801LIQUID CRYSTALDISPLAY PANEL

S801MEGA BASS

STANDBY

IC804

S806SNOOZE

1 2

+TUNING•TIME SET

–

AMS/SEARCH

1

5

^"=~ |

"=~|

11

22

23

2

1

10

3

–

+

1

1

11 15

3

3

5

1 2

VOLUME

1

8180

5150

3130

100

141

PMC-R30L

– 25 – – 26 –

6-7. PRINTED WIRING BOARDS — CONTROL SECTION — • Refer to page 16 for Circuit Boards Location.

D801 F-2D802 G-6D803 G-6D804 F-8D805 F-2D806 D-11

IC801 E-4IC802 H-1IC803 F-6IC804 E-2

Q801 E-6Q802 E-6Q805 F-7Q807 F-2


Ref. No. Location

(Page 21) (Page 30)

PMC-R30L

– 27 –

6-8. SCHEMATIC DIAGRAMS — CONTROL SECTION —

– 28 –

SEL5420E

(Page 24) (Page 33)

PMC-R30L

– 29 – – 30 –

6-9. PRINTED WIRING BOARDS — MAIN SECTION — • Refer to page 16 for Circuit Boards Location.

1

A

B

C

D

E

F

G

H

I

2 3 4 5 6 7 8 9 10 11 12 13

R119R218L101

J301PHONES

POWER BOARDCNP901

L301

R118

L201

R215

R339

D310

R319

R333

R114

R107

R313

R314

R321

R311

R323

R112

R338

R11

R8

R109

R210 R110

R108

R329

R325

R327

R326

R324

R308

R113 R320R337R304

R301

R111R303

1112

13 24

7

R322

R348

R345

R50

R207

R309

R343

R341

R212

R211

R302

R213

R208

R349

R214R3

30

R342

JW13

0JW

131

R221

R121

R350 R3

51

C329D3

01

R312

Q305

R115

R209

R219 R316

R310

R315

R331

Q308

Q309Q3101-674-

299- 11

HEADPHONE BOARD

REC SW BOARD

1-674-298- 11

MAIN BOARD

1-674-297- 11

3 1 CONTROL BOARD

CNP805CD BOARD

CNP704

04

Q10 Q22

Q21D8

JW125

JW67 C68

C77

C71

D302

L12

R47

C69

R45R48

X2

IC3

IC2

X1

R46

C76

JW37

JW70

Q9CF2

CF1

CF3

Q18

D3

Q4

Q2

Q3

Q17

Q13Q15

Q314

Q304Q311

Q12

Q11Q302

Q307

Q14

Q16

C25

C20

C22

CT1

C11

C80

C307

C7CT2CT3

CT4

C28

C34

C27

C14

C5

C47C16

C33

C58

C42

C55

C26

C63 C60

C61C62

C64

C65

C41

C40

C18

C44

C78

C43

C45

C1

R13

JW83JW52

C21

R44R43

R42

R24

R36

L8

R41

R51R26 R40

R35R34

R31

R25

R32

R30

R29

R28

R38

R27

R52

R17

R39

R15R1

8R1

9

R20

R16

R22R23

R21

L11

L6

L1

L7

L9

L2

R54

R14

R5

R9

R10

R3

R2

R49

R53

R33

R56

R1

L103

L102

L203L202

C225

C217

C224

C218 C312

C354

C342

C355 C318

C340

C115C117

C361

C344

C362

C215

C310

C356

C10

C17

C319

C314

C216

C212 C1

12

C317C2

13

C113

C116

C320

CNP307

IC303

C125

C118 C124

JW88

JW20

JW10

0

JW35

JW69

JW26

JW123JW77

D312

D306

JW19

D307

D305

JW59

JW110

JW81

JW92

JW10

JW10

2 JW93

JW11

7

JW11

5JW

116

JW8

JW107JW22

JW103

JW13

JW62

JW21

JW86JW82

JW84

JW132

JW17

JW72

JW10

4 JW85

JW60

JW10

1

D304

JW73 JW

95JW

108

JW58

JW49

JW94

JW31

C339

C111

C123

C315

C334

C205

C201

C202 C3

01

C102

C101

C328

C324

L13

C70 C7

4

C75

C73

C72

C52

C53

C54

C32

C31

C56

C57

C59

L10C3

9

C38 C3

7

C35

C36

C30C2

9

C24

C81

C23

C51

C50

C49

C48

JW12

4

C325

C337

C105

C304

C305

R334

R306

R204

R335

R105

R201

R205

R101

R336

R104

R318

R37

R202

C341

C311

C316

C309

C207

C346

C107

C330

C331

C322

C223

C357

C211

C358

C206

C351C204

C345

C302

C203

CNP301

C103

C104

C364

C335

R305

R307Q303

Q19R203

R102 R103

R346

C332

T301

C353

C352

C336 C338

C313

C323

C360

C359C363

C327C110

C109

C108

C326 C321

C106

C303 C308

C208

C209

C210

D311

JW68

JW96

JW76

JW97

JW64

JW14

JW63

JW61

JW36

JW65

JW24

JW44

JW66

JW90 JW

42 JW79

JW53

JW11

4JW

33

JW12

2

JW39

JW12

1JW

8

JW43

JW30

JW12

0

JW47

JW48

JW40

JW5

JW16

JW34

JW15

JW23

JW11

2

JW11

8JW

28 JW29

JW10

6

JW10

9

JW7

JW6

JW38

JW11

1

JW9

JW98

JW78

JW46

JW10

5

JW11JW99

JW54JW41

JW89

CNP3

02

D308

Q306

Q20L3

02

CNP306

CNP304

CNP303

IC301

Q1

Q7

Q6

Q5

D4

D5

D1

D11

D2

D9

D10

C3

C6

C2

C13

C12

C46

C4

C19

C9C8

JW25JW27

JW55

JW50JW32

JW13JW91JW57

JW12

JW71

JW87

JW45

JW51

JW74

CNP305

IC30

2

Q313

Q312

JW4

Q301

L4L3

R55

L14

R7 R6 R4

CFT1

L5

L15

124

1213

CNP1S824

1

4

4

1

14

6 1

1 32

16 17

JW80

J301SPEAKER

(IMP USE 3Ω)

CNP308

15

SW301(REC/PB)

CNP311

HRP301RECORD/PLAYBACK

HEAD

4

1

15 1

5

1

3

SP301SPEAKER

L-CH

SP302SPEAKER

R-CH

S824RESET

CNP1MW/LW

CNP2FM

S

SS

TU1FM TUNER UNIT

1

4

5

8

12 22

11 1

98

16

22

10

21

23

1

M

M301CAPSTAN/

REEL( )S301

(MD POWER)

S302(MD PLAY)

REC

PB

-1 -2

IC1

12

TP(VT)

S

D1 A-10D2 A-10D3 C-10D4 A-10D5 A-10D6 H-10D8 H-9D9 B-9D10 B-9D11 B-11D12 B-11D301 E-3D302 H-12D304 D-7D305 D-7D306 B-7D307 C-7D308 H-6D310 C-6D311 F-3D312 F-8

IC1 D-10IC2 G-11IC3 H-11IC301 G-5IC302 F-5IC303 C-4

Q1 B-10Q2 C-11Q3 C-11Q4 C-10Q5 B-9Q6 C-8Q7 B-8Q9 E-10Q10 I-9Q12 G-9Q13 F-9Q14 F-10Q15 F-8Q16 F-12Q17 F-12Q18 E-9Q19 H-4Q20 H-7Q21 H-10Q22 I-9Q301 H-3Q302 G-8Q303 I-4Q304 E-6Q305 E-4Q306 H-6Q307 G-7Q308 C-6Q309 C-6Q310 C-7Q312 H-3Q313 F-3Q314 F-7


Ref. No. Location

(Page 21) (Page 25)

(Page 35)

6-10. SCHEMATIC DIAGRAM — MAIN SECTION (1/2) — • Refer to page 38 for IC Block Diagrams.

PMC-R30L

– 31 – – 32 –

INV

(Page 33)


PMC-R30L

– 33 – – 34 –

6-11. SCHEMATIC DIAGRAM — MAIN SECTION (2/2) — • Refer to page 39 for IC Block Diagrams.

2SB1015Y

L102 1.1µH

L202 1.1µH

(Page32)

(Page27)

(Page 35)

(Page 24)

– 35 –

6-12. PRINTED WIRING BOARD — POWER SUPPLY SECTION —• Refer to page 16 for Circuit Boards Location.

6-13. SCHEMATIC DIAGRAM — POWER SUPPLY SECTION —

1

A

B

C

D

E

2 3 4 5 6 7

POWER BOARD

1-674-304- 11

4 MAIN BOARD

CNP305

JW901

T901POWER TRANSFORMER

D903

D904

04

D905

F901

AC IN

CNP901

CNP902

C906

C905

F902C9

04

D902

C902

C901

D901

C903

R901

1 3

PMC-R30L

(Page 29)

(Page 34)


– 36 –

• IC Block Diagrams

IC701 CXA1992BR

CHARGEUP

FSET

TRACKINGPHASE COMPENSATION

FOCUSPHASE COMPENSATION

40FE BIAS

41F

42E

43EI

44VEE

45TEO

46LPF1

47TEI

48ATSC

49TZC

50TDFCT

51VC

52FZC

26 SENS2

25 SENS1

24 C OUT

23 XRST

22 DATA

21 XLT

20 CLK

19 LOCK

VCC

17 ISET

16 SL O

SL M

SL P

39

PD2

PD1

38 37

PD0

36

LD

35

RFTC

34

RF M

33

RF O

32

RF I

31

CP

30

CB

29

CC1

28

CC2

27

FOK

1

FEO FEI

FDFC

T

FGD

FLB

FE O

7

FE M

8

SRCH

9

TGU

10

TG2

11

FSET

12

TA M

13

TA O

TM2

TM6TM4

TM7

TM5

TM3

VEEVEETG2

VCC

FS1

FS2

FS4

TG1

TM1

DFCT

DFCT

VEE

VCC

ISET

VCC

VCC

FZC COMP

VCC

VCC

VEE

TZC COMP

ATSCWINDOW

COMP

E-F BALANCEWINDOW COMP

TOG1

BAL1

BAL2

BAL3

BAL4

IFB1

IFB2

IFB3

IFB4

IFB5

IFB6

TOG2

TOG3

TOG4

E IV AMP

F IV AMP

PD2 IVAMP

PD1 IVAMP

VCCAPC

VCC

VEETGFL

VEE

VEE

VEELASER POWER CONTROL

FE AMP

RF SUMMING AMP

FO BIASWINDOW

COMP

FOK

TRK GAINWINDOW COMP

VCC

DFCT

VCC

VCC

VEE

VEE

MIRR

VEE

IIL

IIL

TTL

IIL

TTL

TTL

CC1

DFCT

1

MIR

R

LDON

LPCL

LPC

TGFL

FOHFOLTGHTGL

BALHBALLATSC

TZCFZC

IIL DATA REGISTERINPUT SHIFT REGISTER

SENS SELECTOROUTPUT DECODER

DFCTO IFB1–6BAL1–4TOG1–4

FS1–4 TG1–2 TM1–7 PS1–4

4 5 632

14

15

18

LEVE

L 9

– 37 –

IC703 CXD2589Q

PWM

PWM

1 2 3 4 5 6 12 13 14 15 16 17 19 20

34

27

24

23

25

21

61

63

64

6667686970

71

72

73

7475

77787980

OSC

62

65

76

7 8 9 10 11 18

22

28

26

33

32

31

30

29

36

35

40

39

38

37

45 44 43 42 4150 49 48 47 4655 54 53 52 5159 58 57 5660

EFMDEMODULATOR

ERRORCORRECTOR

16kRAM

D/AINTERFACE

CLOCKGENERATOR

SERVOAUTO

SEQUENCER

CPUINTERFACE

DIGITALOUT

SUB CODEPROCESSOR

3rd-ORDERNOISE SHAPER

OVER SAMPLINGDIGITAL FILTER

SERIAL-ININTERFACE

DIGITALCLV

OSC

DIGITALPLL

ASYMMETRYCORRECTOR

LRCKI

LRCK

ASYO

ASYI

BIAS

RF

AVDD

CLTV

AVSS

FILI

FILO

PCO

V16MVCTL

VCKIVPCO1

TES1

TES0

PWMI

MDP

VDDSYSM

AVSS

AVDD

XTAIXVDDAVSS

LOUT1AIN1

AOUT1

XTAO

XVSS

AVSS

LOUT2AIN2

AOUT2

AVDDAVSSXRSTVDD

VSS

EXCK

SBSO

SCOR

WFC

K

ENPH

I

EMPH

DOUT

C4M

XTSL

C2PO

GFS

XPCK

XUGF

VDD

VSS

BCKI

BCK

PCM

DI

PCM

D

VSS

LMUT

ERM

UTE

SQCK

SQSO

SENS

DATA

XLAT

CLOK

SEIN

CNIN

DATO

XLTO

CLKO

SPOA

SPOB

XLON FO

KVD

DVS

S

1 2 3 4 5 6 7 8 9 10 11 12 13 14

28 27 26 24 23 22 21 20 19 18 17 16 1525

LEVE

LSH

IFT

LEVE

LSH

IFT

LEVE

LSH

IFT

D.BU

F

D.BU

F

LEVE

LSH

IFT

D.BU

F

D.BU

F

D.BU

FGN

D

F– F+ FIN

NC VREF

VCC

VCC

NC TIN

T– T+ NC SPI

SL–

SL+

SLIN

RESE

T

REGB

REGO

MUT

E

GND

SPIN NC SP–

SP+

GND

SPO

D.BU

FD.

BUF

D.BU

F

REGULATOR

DRIV

ER-

MUT

E

VCC

VCC

IC702 BA6898FP

– 38 –

IC1 TA2104BN

IC2 BU2615S

2

19

11

181720

13

1

16

15

3

4

5

6

7

PRESCALER MAIN COUNT

REFERENCE DIVIDER

I/OCTL

8

14

SHIFT REGISTER LATCH

PHASEDET

BUFFER

IF COUNTCTL

20BIT COUNT

12109

ULLO

CK

P5

PD1

PD2/P5

VDD1VDD2VSS

IF IN

P3 P4 P6

P2

P1

P0

CD

DA

CK

CE

AMIN

FMIN

XOUT

XIN

GND1

3

2

1

IF REQ

AMMIX

FM RF IN

AM LOW CUT

5

4MIX OUT

VCC2

AF IF IN

8

7

6

FM IF IN

GND2

10

9AGC

QUAD

12

11R-OUT

L-OUT

FM RF OUT

22

23

24

20

21

17

18

19

15

16

13

14

AM RF IN

VCC1

FM OSC

ST IND

OSC OUT

AM OSC

IF OUT

LPF2/MO-ST

MPX IN

DET OUT

LPF1/BAND

FMMIX

FMOSC

LEVELDET

AMDET

MUTE

FMDET

ST/MOFM/AM

AMOSC

AGC

SW

ST

1/8

BUFFBUFF

DIVIDE

DECODE

VCO

IF BUFF

AF BUFF

AF

FM RF

AM IF

FM IF

– 39 –

IC3 BU1924

2

1

3

4

16

14

13

15

12

11

109

567

8

VREF

ANALOG

RCLK

(NC)

X2

X1

VDD2

VSS2

T1T2

DIGITAL

QUAL

RDATA

VREF

MUX

VDD1VSS1VSS3

CMP

TEST

PLL57KHz

RDS/ARICLOCK

&DRIVER

DEFFERENTIALDECODER

BIPHASEDECODER

PLL1187.5Hz

ANTI-ALIASING 8TH SWITCHEDCAPACITOR FILTER COMPARATOR

1

2

3

6

9

10

11

12

8

7

4

5

22

TAPE

TAPE

TAPE

BUF AMPA1

BUF AMPA2

NABAMP1

NABAMP2

23

24

15

14

13

21

20

17

16

RADIO

BUF AMPB1

BUF AMPB2

MUTE

MUT

E

ON

ON

ON

7dB

26dB

26dB

MONITORAMP

LOGIC

18

19

MUTE

7dB

MONITORAMP

LINE

TAPERADIO

LINE

ALC2

ALC1

DET

RECAMP1

RECAMP2

2.1

REFAMP

MICAMP1

LINEIN1INTEXTRADIOIN1RECPLAY

PREOUT1

PREOUT2

RADIOLINE

RADIOIN2

LINEIN2

MICIN

TAPETAPE

VCC

ALCNAB

OUT1

NABNF1

RECOUT1NABIN1

VREF

GND

NABIN2

RECOUT2

NABNF2

NABOUT2

MICNF

45678

9101112

13

14

1516

TONE

VR

MATRIXSURROUND

CONT

ROL

123

AGNDIN1NF1

BVN1BIN1

BVO1TIN1

TVO1

OUT1VCC

SCPORT1

PORT2

PORT3

PORT4DGND

24

23222120191817

TONE

VR

FILTERIN2NF2

BVN2BIN2BVO2TIN2TVO2

OUT2

VCTCBCCKDATALATCHVREF

323130

2928272625

1 2 3 6 9 10 11 12874 5 151413

FILTERBS STBYBS

NC BS2

OUT2

VCC

OUT1 BS1

POW

ER G

ND

ST B

Y

FILT

ER NF1

IN1

IN2

NF2

PRE

GND1

PRE

GND2

IC301 TA2068N

IC303 BA5417

IC302 BH3854AFS

– 40 –

SECTION 7EXPLODED VIEWS

NOTE:• The mechanical parts with no reference

number in the exploded views are not supplied.• Items marked “*” are not stocked since

they are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• Color Indication of Appearance PartsExample :

KNOB, BALANCE (WHITE) ... (RED)

Parts Color Cabinet’s Color

Ref. No. Part No. Description Remark

7-1. CABINET (REAR) SECTION

N N


• Accessories and packing materials andhardware (# mark) list are given inthe last of this parts list.

The components identified bymark ! or dotted line with mark.! are critical for safety.Replace only with part numberspecified.

* 1 A-3322-170-A MAIN BOARD, COMPLETE2 3-703-244-00 BUSHING (2104), CORD!3 1-575-651-21 CORD, POWER

4 3-026-310-01 FOOT* 5 1-674-304-11 POWER BOARD

6 3-042-212-01 TAG, SOLDER7 3-042-214-01 CABINET (REAR)

!F901 1-532-500-31 FUSE, TIME-LAG (T630mAL/250V)!F902 1-532-465-31 FUSE, TIME-LAG (T3.15AL/250V)

IC303 8-759-426-51 IC BA5417Q308 8-729-021-82 TRANSISTOR 2SD2396KQ310 8-729-141-83 TRANSISTOR 2SB1094-LK

!T901 1-431-972-11 TRANSFORMER, POWER

1

3

4

2

7

5

6

#3

#2

#2

#2

#2

IC303

Q310

Q308

#2

#1

T901

F901

F902

not supplied

notsupplied

#4

#4

#4

#1

#1

#1

– 41 –

7-2. CABINET (FRONT) SECTION

Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark

* 51 1-674-300-11 BACK LIGHT BOARD52 3-042-215-01 COVER (FRONT)53 3-926-926-01 GEAR, DAMPER54 A-3328-449-A CASSETTE ASSY, DOOR55 3-025-499-01 HOLDER, CASSETTE

56 3-026-310-01 FOOT* 57 A-3322-164-A CONTROL BOARD, COMPLETE

58 3-039-911-01 LENS, RDS* 59 3-039-913-01 HOLDER, LCD* 60 3-039-914-01 HOLDER, LED

* 61 A-3322-163-A KEY BOARD, COMPLETE62 1-791-980-11 CABLE, FFC 23P

* 63 1-674-299-11 HEADPHONE BOARD

64 3-026-322-01 SPRING, CASSETTE UP65 3-025-508-01 BUTTON (REC)66 3-025-511-01 BUTTON (PLAY)67 3-025-510-01 BUTTON (REW)68 3-025-509-01 BUTTON (FF)

69 3-025-512-01 BUTTON (STOP)70 3-025-507-01 BUTTON (PAUSE)71 3-042-216-01 CABINET (FRONT)72 3-039-915-01 LENS (RDS HOLDER)73 4-960-167-01 SCREW (3X8) (DIA. 10)

D804 8-719-989-85 LED SLR34VR3FM.N (STANDBY)LCD801 1-803-762-11 DISPLAY PANEL, LIQUID CRYSTAL

#2

#2

#2

#2

#1

#1

#2

#1

#5

#5

#2

#2

#1

LCD801

not supplied

D804

not supplied

not supplied

not supplied

MF-107

54

55

5652

58

65

64

51

63

62

59

57

6061

53

71

72

6667

6869 70

73

– 42 –

7-3. CABINET (UPPER) SECTION


101 3-025-506-01 WINDOW, CD102 3-025-505-01 CD LID103 1-452-732-11 MAGNET104 3-021-020-01 PLATE, CHUCKING105 3-026-314-01 BRACKET (LIFT)

106 3-026-325-01 SPRING (COMP)107 1-658-023-31 CD MOTOR BOARD108 3-026-315-01 SPRING, CD UP109 3-025-504-01 CABINET (UPPER)

110 3-926-926-01 GEAR, DAMPER* 111 A-3322-168-A CD BOARD, COMPLETE

112 1-769-824-11 WIRE (FLAT TYPE) (16 CORE)113 3-022-370-01 RUBBER, VIBRATION PROOF114 3-022-370-11 RUBBER, VIBRATION PROOF

115 3-923-736-01 COVER, CD116 3-916-006-01 SCREW (2.6X16)117 3-042-213-01 SHEET, PLASTICSW701 1-692-960-11 SWITCH, PUSH (1 KEY) (CD DOOR)

SW701

#1

#6

#1

#1

KSM-213CDM

101

102105

106

108

110

109

103

104 115

113

113

116

116

114

114

116

116

107

112

111

117

– 43 –

7-4. TAPE MECHANISM SECTION-1(MF-107)


151 3-907-720-01 FW ASSY152 3-369-961-01 WASHER153 3-362-989-01 BELT154 3-362-970-01 SPRING155 3-362-971-01 SPRING

* 156 3-362-988-01 HOLDER, MOTOR157 3-362-980-01 WASHER

158 3-379-843-01 SPRING159 3-026-316-01 SPRING, REC160 3-362-967-01 SPRING, CASSETTE

* 161 1-674-298-11 REC SW BOARDM301 X-3365-538-1 MOTOR ASSY (CAPSTAN/REEL)

S301 1-571-556-11 SWITCH, LEAF (MD POWER)S302 1-571-556-11 SWITCH, LEAF (MD PLAY)

151

152

153

154155

156

159160

157158

161

S301

S302

M301

#7

#7

#9

#8

#6

#6

– 44 –



201 3-366-352-01 SCREW202 3-369-961-01 WASHER203 3-369-962-01 SPRING, COMPRESSION204 X-3363-315-1 GEAR ASSY, CAM205 3-362-973-01 AS (BASE)

206 3-362-976-01 LEVER, CONTROL

207 3-362-975-01 LEVER, SENSOR208 3-362-977-01 SPRING209 3-362-978-01 SPRING, PLATE210 3-379-844-01 PLATE, STOP, FR211 3-387-697-01 SENSOR

212 3-362-969-01 IDLER ASSY, PF

201

202

203

204

205

206

207

208

211

212

210

209

– 45 –



251 X-3363-611-1 REEL ASSY, S252 3-917-805-01 SPRING253 3-382-408-01 SCREW254 3-362-962-01 REEL ASSY, T255 3-362-965-01 IDLER, FF

256 3-362-961-01 SPINDLE (BASE)257 3-362-966-01 INTER LOCK

258 3-362-960-01 PULLEY, IDLER259 3-362-956-01 SPRING260 3-362-957-01 SPRING261 3-362-959-01 ARM, IDLER262 3-362-968-01 LEVER, EJECT

HRP301 1-543-964-12 HEAD, MAGNETIC (RECORD/PLAYBACK)

251

252

255

256

257

259

261

258

262

260

253

254

#9

HRP301

– 46 –



301 3-382-409-01 GUIDE TAPE AZ302 3-362-983-01 SPRING303 3-382-407-01 BASE HEAD304 3-362-982-01 PINCH ROLLER305 3-362-981-01 PINCH ARM

306 3-362-944-01 STOPPER, REC307 3-362-945-01 SPRING308 3-362-942-01 FRAME ASSY

* 309 3-362-943-01 PLATE, FUNCTION* 310 3-362-946-01 LEVER, SW

311 3-362-958-01 SCREW312 3-362-954-01 SPRING

313 3-362-955-01 SPRING* 314 3-362-947-01 LEVER, REC* 315 3-362-948-01 LEVER, PLAY* 316 3-362-949-01 LEVER, REW* 317 3-362-950-01 LEVER, FF

* 318 3-362-951-01 LEVER, SE* 319 3-362-952-01 LEVER, PAUSE

320 3-362-953-01 ARM, PAUSE* 321 3-362-941-01 CHASSIS

322 3-362-987-01 ARM, EH

HE301 1-543-876-11 HEAD (ERASE)

HE301

#10

#10

321

320

319

318

313

310

309

308

305304

302

301

303

306

307

311

312

314

317316

315

322

– 47 –


7-8. OPTICAL PICK-UP SECTION(KSM-213CDM)

351 2-626-908-01 SHAFT, SLED352 3-713-786-51 SCREW +P 2X3!353 8-848-483-05 PICK-UP, OPTICAL KSS-213C

354 2-627-003-02 GEAR (B) (RP)

355 X-2626-202-1 CHASSIS ASSY (MB), MOTOR (SPINDLE)(INCLUDING M701)

M702 X-2625-769-1 GEAR ASSY (MB) (RP), MOTOR (SLED)

354

355351

353

not suppliednot supplied

M702

352

M701


– 48 –

7-9. SPEAKER SECTION


401 A-3328-452-A NET ASSY, SPEAKER402 3-025-513-01 CABINET, SPEAKER (FRONT)

* 403 3-933-229-01 STOPPER, CORD404 3-025-514-01 CABINET, SPEAKER (REAR)405 3-026-310-01 FOOT

* 406 3-026-158-01 SPACER (SOURCE)407 3-918-371-01 CUSHIONSP301 1-505-395-21 SPEAKER (10cm) (L-CH)SP302 1-505-395-21 SPEAKER (10cm) (R-CH)

403

405

405406

406

406

407

402

401

404

#4

#4

#1

#11

#11

#1SP301 (L-CH)SP302 (R-CH)

– 49 –

CDSECTION 8

ELECTRICAL PARTS LIST

NOTE:• Due to standardization, replacements in

the parts list may be different from theparts specified in the diagrams or thecomponents used on the set.

• RESISTORSAll resistors are in ohms.METAL:Metal-film resistor.METAL OXIDE: Metal oxide-film resistor.F:nonflammable

• AbbreviationCET : East European & CIS modelIT : Italian model

• Items marked “*” are not stocked sincethey are seldom required for routine service.Some delay should be anticipatedwhen ordering these items.

• SEMICONDUCTORSIn each case, u : µ, for example:uA.. : µA.. uPA.. : µPA..uPB.. : µPB.. uPC.. : µPC.. uPD.. : µPD..

• CAPACITORSuF : µF

• COILSuH : µH



When indicating parts by referencenumber, please include the board.

* 1-674-300-11 BACK LIGHT BOARD*****************

< CONNECTOR >

CNP804 1-580-163-11 PIN, CONNECTOR (PC BOARD) 2P

< SWITCH >

S805 1-762-196-21 SWITCH, TACTILE (SNOOZE)S806 1-762-196-21 SWITCH, TACTILE (SNOOZE)

*************************************************************

* A-3322-168-A CD BOARD, COMPLETE*******************

1-769-824-11 WIRE (FLAT TYPE) (16 CORE)

< CAPACITOR >

C701 1-162-600-11 CERAMIC 0.0047uF 20% 16VC702 1-162-306-11 CERAMIC 0.01uF 30% 16VC703 1-130-481-00 MYLAR 0.0068uF 5% 50VC704 1-130-491-00 MYLAR 0.047uF 5% 50VC705 1-162-306-11 CERAMIC 0.01uF 30% 16V

C706 1-104-664-11 ELECT 47uF 20% 10VC707 1-161-494-00 CERAMIC 0.022uF 25VC708 1-130-495-00 MYLAR 0.1uF 5% 50VC709 1-164-159-21 CERAMIC 0.1uF 50VC710 1-162-302-11 CERAMIC 0.0022uF 20% 16V

C711 1-162-199-31 CERAMIC 10PF 5% 50VC712 1-162-294-31 CERAMIC 0.001uF 10% 50VC713 1-130-495-00 MYLAR 0.1uF 5% 50VC714 1-164-159-21 CERAMIC 0.1uF 50VC715 1-126-233-11 ELECT 22uF 20% 50V

C716 1-130-495-00 MYLAR 0.1uF 5% 50VC717 1-130-483-00 MYLAR 0.01uF 5% 50VC718 1-124-907-11 ELECT 10uF 20% 50VC719 1-104-664-11 ELECT 47uF 20% 10VC720 1-130-483-00 MYLAR 0.01uF 5% 50V

C721 1-130-489-00 MYLAR 0.033uF 5% 50VC722 1-130-489-00 MYLAR 0.033uF 5% 50VC723 1-162-306-11 CERAMIC 0.01uF 30% 16VC724 1-130-489-00 MYLAR 0.033uF 5% 50VC725 1-130-486-00 MYLAR 0.018uF 10% 50V

C726 1-164-159-21 CERAMIC 0.1uF 50VC727 1-162-199-31 CERAMIC 10PF 5% 50VC728 1-104-664-11 ELECT 47uF 20% 10V

C729 1-126-962-11 ELECT 3.3uF 20% 50VC730 1-130-493-00 MYLAR 0.068uF 5% 50VC731 1-162-215-31 CERAMIC 47PF 5% 50VC732 1-130-483-00 MYLAR 0.01uF 5% 50VC733 1-162-306-11 CERAMIC 0.01uF 30% 16V

C734 1-162-302-11 CERAMIC 0.0022uF 20% 16VC737 1-162-306-11 CERAMIC 0.01uF 30% 16VC738 1-162-282-31 CERAMIC 100PF 10% 50VC739 1-162-282-31 CERAMIC 100PF 10% 50VC740 1-162-294-31 CERAMIC 0.001uF 10% 50V

C741 1-130-485-00 MYLAR 0.015uF 5% 50VC742 1-162-306-11 CERAMIC 0.01uF 30% 16VC743 1-104-664-11 ELECT 47uF 20% 10VC744 1-124-472-11 ELECT 470uF 20% 10VC745 1-124-443-00 ELECT 100uF 20% 10V

C748 1-124-443-00 ELECT 100uF 20% 10VC749 1-162-303-11 CERAMIC 0.0033uF 30% 16VC750 1-162-282-31 CERAMIC 100PF 10% 50VC751 1-162-306-11 CERAMIC 0.01uF 30% 16VC752 1-162-306-11 CERAMIC 0.01uF 30% 16V

C753 1-124-443-00 ELECT 100uF 20% 10VC754 1-162-292-31 CERAMIC 680PF 10% 50VC755 1-164-159-21 CERAMIC 0.1uF 50VC756 1-162-306-11 CERAMIC 0.01uF 30% 16VC757 1-162-284-31 CERAMIC 150PF 10% 50V

C758 1-162-286-21 CERAMIC 220PF 10% 50VC759 1-124-443-00 ELECT 100uF 20% 10VC760 1-136-173-00 FILM 0.47uF 5% 50VC761 1-162-199-31 CERAMIC 10PF 5% 50VC762 1-162-282-31 CERAMIC 100PF 10% 50V

C763 1-162-290-31 CERAMIC 470PF 10% 50VC764 1-162-199-31 CERAMIC 10PF 5% 50VC765 1-162-286-21 CERAMIC 220PF 10% 50VC766 1-162-306-11 CERAMIC 0.01uF 30% 16VC767 1-126-963-11 ELECT 4.7uF 20% 50V

C768 1-162-306-11 CERAMIC 0.01uF 30% 16VC769 1-136-169-00 FILM 0.22uF 5% 50VC770 1-126-963-11 ELECT 4.7uF 20% 50VC772 1-162-306-11 CERAMIC 0.01uF 30% 16VC773 1-124-443-00 ELECT 100uF 20% 10V

C774 1-162-302-11 CERAMIC 0.0022uF 20% 16VC775 1-162-306-11 CERAMIC 0.01uF 30% 16VC776 1-162-306-11 CERAMIC 0.01uF 30% 16VC777 1-162-306-11 CERAMIC 0.01uF 30% 16VC778 1-162-292-31 CERAMIC 680PF 10% 50V

BACK LIGHT

– 50 –


CD CD MOTOR

C779 1-162-284-31 CERAMIC 150PF 10% 50VC782 1-137-374-11 FILM 0.047uF 5% 50VC783 1-137-374-11 FILM 0.047uF 5% 50V

< CONNECTOR >

CNP701 1-770-168-11 CONNECTOR, FFC/FPC 16P* CNP702 1-774-957-11 PIN, CONNECTOR (PC BOARD) 11P* CNP703 1-564-708-11 PIN, CONNECTOR (SMALL TYPE) 6P* CNP704 1-580-159-11 PIN, CONNECTOR (PC BOARD) 7P

< FERRITE BEAD >

FB701 1-410-397-21 FERRITE BEAD INDUCTORFB702 1-410-397-21 FERRITE BEAD INDUCTOR

< IC >

IC701 8-752-082-14 IC CXA1992BRIC702 8-759-473-42 IC BA6898FPIC703 8-752-384-13 IC CXD2589Q

< COIL >

L701 1-410-509-11 INDUCTOR 10uHL702 1-410-509-11 INDUCTOR 10uHL703 1-410-509-11 INDUCTOR 10uHL704 1-410-509-11 INDUCTOR 10uHL705 1-410-509-11 INDUCTOR 10uH

< TRANSISTOR >

Q701 8-729-037-13 TRANSISTOR KTA1271Y

< RESISTOR >

R701 1-249-440-11 CARBON 82K 5% 1/4WR702 1-249-441-11 CARBON 100K 5% 1/4WR703 1-249-441-11 CARBON 100K 5% 1/4WR704 1-249-441-11 CARBON 100K 5% 1/4WR705 1-249-441-11 CARBON 100K 5% 1/4W


R712 1-247-891-00 CARBON 330K 5% 1/4WR713 1-249-429-11 CARBON 10K 5% 1/4WR714 1-249-429-11 CARBON 10K 5% 1/4WR715 1-249-429-11 CARBON 10K 5% 1/4WR716 1-247-852-11 CARBON 7.5K 5% 1/4W

R717 1-247-903-00 CARBON 1M 5% 1/4WR718 1-247-899-11 CARBON 680K 5% 1/4WR719 1-249-393-11 CARBON 10 5% 1/4WR720 1-249-431-11 CARBON 15K 5% 1/4WR721 1-249-435-11 CARBON 33K 5% 1/4W

R722 1-247-886-11 CARBON 200K 5% 1/4WR723 1-247-896-11 CARBON 510K 5% 1/4WR724 1-249-439-11 CARBON 68K 5% 1/4W


R730 1-249-435-11 CARBON 33K 5% 1/4WR731 1-247-863-00 CARBON 22K 5% 1/4WR732 1-249-417-11 CARBON 1K 5% 1/4WR733 1-247-843-11 CARBON 3.3K 5% 1/4WR734 1-247-843-11 CARBON 3.3K 5% 1/4W

R735 1-249-430-11 CARBON 12K 5% 1/4WR736 1-247-863-00 CARBON 22K 5% 1/4WR737 1-247-843-11 CARBON 3.3K 5% 1/4WR738 1-249-435-11 CARBON 33K 5% 1/4WR741 1-249-417-11 CARBON 1K 5% 1/4W


R747 1-249-428-11 CARBON 8.2K 5% 1/4WR748 1-247-890-11 CARBON 300K 5% 1/4WR749 1-249-430-11 CARBON 12K 5% 1/4WR750 1-249-430-11 CARBON 12K 5% 1/4WR751 1-249-430-11 CARBON 12K 5% 1/4W

R752 1-249-430-11 CARBON 12K 5% 1/4WR753 1-249-430-11 CARBON 12K 5% 1/4WR754 1-247-887-00 CARBON 220K 5% 1/4WR755 1-249-429-11 CARBON 10K 5% 1/4WR756 1-247-903-00 CARBON 1M 5% 1/4W

R757 1-249-417-11 CARBON 1K 5% 1/4WR758 1-249-437-11 CARBON 47K 5% 1/4WR759 1-249-437-11 CARBON 47K 5% 1/4W

< VIBRATOR >

X701 1-579-345-11 VIBRATOR, CERAMIC (16.9344MHz)*************************************************************

1-658-023-31 CD MOTOR BOARD****************

< CONNECTOR >

CNP707 1-564-722-11 PIN, CONNECTOR (SMALL TYPE) 6P

< SWITCH >

S701 1-572-085-11 SWITCH, LEAF (LIMIT)*************************************************************

– 51 –


CONTROL

* A-3322-164-A CONTROL BOARD, COMPLETE*************************

1-791-980-11 CABLE, FFC 23P* 3-039-913-01 HOLDER, LCD* 3-039-914-01 HOLDER, LED

7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S

< CAPACITOR >

C801 1-162-306-11 CERAMIC 0.01uF 30% 16VC802 1-162-306-11 CERAMIC 0.01uF 30% 16VC803 1-162-306-11 CERAMIC 0.01uF 30% 16VC804 1-162-306-11 CERAMIC 0.01uF 30% 16VC805 1-162-306-11 CERAMIC 0.01uF 30% 16V

C806 1-162-210-31 CERAMIC 30PF 5% 50VC807 1-162-210-31 CERAMIC 30PF 5% 50VC808 1-162-210-31 CERAMIC 30PF 5% 50VC809 1-162-210-31 CERAMIC 30PF 5% 50VC810 1-164-159-21 CERAMIC 0.1uF 50V

C811 1-164-159-21 CERAMIC 0.1uF 50VC813 1-162-294-31 CERAMIC 0.001uF 10% 50VC814 1-162-294-31 CERAMIC 0.001uF 10% 50VC815 1-162-294-31 CERAMIC 0.001uF 10% 50VC816 1-162-282-31 CERAMIC 100PF 10% 50V

C817 1-162-282-31 CERAMIC 100PF 10% 50VC818 1-162-282-31 CERAMIC 100PF 10% 50VC820 1-125-705-11 DOUBLE LAYERS 0.22F 5.5VC821 1-162-205-31 CERAMIC 18PF 5% 50VC822 1-162-205-31 CERAMIC 18PF 5% 50V

C823 1-124-903-11 ELECT 1uF 20% 50VC824 1-104-664-11 ELECT 47uF 20% 10VC825 1-164-159-21 CERAMIC 0.1uF 50VC826 1-162-306-11 CERAMIC 0.01uF 30% 16VC827 1-124-907-11 ELECT 10uF 20% 50V

C828 1-126-961-11 ELECT 2.2uF 20% 50VC829 1-162-306-11 CERAMIC 0.01uF 30% 16VC830 1-162-306-11 CERAMIC 0.01uF 30% 16VC831 1-162-306-11 CERAMIC 0.01uF 30% 16VC832 1-110-671-31 CERAMIC 47000PF 50V

C833 1-124-903-11 ELECT 1uF 20% 50VC835 1-162-306-11 CERAMIC 0.01uF 30% 16VC836 1-162-306-11 CERAMIC 0.01uF 30% 16VC837 1-162-306-11 CERAMIC 0.01uF 30% 16VC838 1-161-494-00 CERAMIC 0.022uF 25V

< CONNECTOR >

* CNP802 1-580-166-11 PIN, CONNECTOR (PC BOARD) 5PCNP805 1-568-865-11 PIN, CONNECTOR (PC BOARD) 23P

* CNP806 1-766-594-11 PIN, CONNECTOR (PC BOARD) 11P

< DIODE >

D801 8-719-991-33 DIODE 1SS133T-77D802 8-719-991-33 DIODE 1SS133T-77D803 8-719-991-33 DIODE 1SS133T-77

D804 8-719-989-85 LED SLR34VR3FM.N (STANDBY)D805 8-719-991-33 DIODE 1SS133T-77

< IC >

IC801 8-752-909-10 IC CXP83232A-015QIC802 8-759-339-53 IC GP1U28XBIC803 8-759-708-05 IC NJM78L05AIC804 8-759-165-86 IC PST600I-T

< COIL >

L801 1-410-087-31 INDUCTOR 10mHL804 1-419-150-11 COIL, PEAKING 10uH

< LIQUID CRYSTAL DISPLAY >

LCD801 1-803-762-11 DISPLAY PANEL, LIQUID CRYSTAL

< TRANSISTOR >

Q801 8-729-922-66 TRANSISTOR 2SC2410SNQ802 8-729-922-66 TRANSISTOR 2SC2410SNQ803 8-729-119-78 TRANSISTOR 2SC2785-HFEQ805 8-729-029-94 TRANSISTOR DTC143TSAQ807 8-729-230-45 TRANSISTOR 2SC2458-YGR

< RESISTOR >

R801 1-247-843-11 CARBON 3.3K 5% 1/4WR802 1-249-420-11 CARBON 1.8K 5% 1/4WR803 1-249-418-11 CARBON 1.2K 5% 1/4WR804 1-249-416-11 CARBON 820 5% 1/4WR805 1-249-415-11 CARBON 680 5% 1/4W

R806 1-249-427-11 CARBON 6.8K 5% 1/4WR807 1-249-437-11 CARBON 47K 5% 1/4WR808 1-249-437-11 CARBON 47K 5% 1/4WR809 1-249-437-11 CARBON 47K 5% 1/4WR810 1-249-441-11 CARBON 100K 5% 1/4W

R811 1-249-403-11 CARBON 68 5% 1/4WR812 1-249-429-11 CARBON 10K 5% 1/4WR813 1-249-417-11 CARBON 1K 5% 1/4WR814 1-249-415-11 CARBON 680 5% 1/4WR815 1-249-441-11 CARBON 100K 5% 1/4W

R816 1-249-427-11 CARBON 6.8K 5% 1/4WR817 1-247-815-00 CARBON 220 5% 1/4WR818 1-247-887-00 CARBON 220K 5% 1/4WR825 1-249-429-11 CARBON 10K 5% 1/4WR832 1-249-429-11 CARBON 10K 5% 1/4W

R835 1-249-413-11 CARBON 470 5% 1/4WR836 1-249-421-11 CARBON 2.2K 5% 1/4WR837 1-249-417-11 CARBON 1K 5% 1/4WR839 1-249-417-11 CARBON 1K 5% 1/4WR840 1-249-417-11 CARBON 1K 5% 1/4W

R841 1-249-417-11 CARBON 1K 5% 1/4WR842 1-249-417-11 CARBON 1K 5% 1/4WR843 1-249-417-11 CARBON 1K 5% 1/4WR844 1-249-417-11 CARBON 1K 5% 1/4W

– 52 –


KEYCONTROL HEADPHONE

R845 1-249-417-11 CARBON 1K 5% 1/4WR846 1-249-417-11 CARBON 1K 5% 1/4WR847 1-249-417-11 CARBON 1K 5% 1/4WR848 1-249-417-11 CARBON 1K 5% 1/4WR849 1-249-417-11 CARBON 1K 5% 1/4WR850 1-249-417-11 CARBON 1K 5% 1/4W




R866 1-249-425-11 CARBON 4.7K 5% 1/4WR867 1-249-425-11 CARBON 4.7K 5% 1/4WR868 1-249-425-11 CARBON 4.7K 5% 1/4WR869 1-249-425-11 CARBON 4.7K 5% 1/4WR870 1-247-807-11 CARBON 100 5% 1/4W

R871 1-249-429-11 CARBON 10K 5% 1/4WR872 1-247-815-00 CARBON 220 5% 1/4WR873 1-260-076-11 CARBON 10 5% 1/2WR874 1-247-807-11 CARBON 100 5% 1/4WR875 1-249-417-11 CARBON 1K 5% 1/4W

R876 1-249-417-11 CARBON 1K 5% 1/4WR877 1-249-417-11 CARBON 1K 5% 1/4WR878 1-249-417-11 CARBON 1K 5% 1/4WR879 1-247-807-11 CARBON 100 5% 1/4WR880 1-249-437-11 CARBON 47K 5% 1/4W

R881 1-249-401-11 CARBON 47 5% 1/4WR882 1-249-417-11 CARBON 1K 5% 1/4WR883 1-249-406-11 CARBON 120 5% 1/4W

< SWITCH >

S801 1-762-196-21 SWITCH, TACTILE (MEGA BASS)S802 1-762-196-21 SWITCH, TACTILE (VOLUME –)S803 1-762-196-21 SWITCH, TACTILE (VOLUME +)S807 1-762-196-21 SWITCH, TACTILE (OPERATE)

< VIBRATOR >

X801 1-567-132-00 OSCILLATOR, CERAMIC (8MHz)X802 1-760-305-11 VIBRATOR, CRYSTAL (32.768kHz)

*************************************************************

* 1-674-299-11 HEADPHONE BOARD*****************

< CONNECTOR >

* CNP308 1-564-520-11 PLUG, CONNECTOR 5P

< JACK >

J302 1-568-267-11 JACK (PHONES)

< COIL >

L101 1-410-521-11 INDUCTOR 100uHL201 1-410-521-11 INDUCTOR 100uHL301 1-410-501-11 INDUCTOR 2.2uH

< RESISTOR >

R118 1-249-404-00 CARBON 82 5% 1/4WR218 1-249-404-00 CARBON 82 5% 1/4W

*************************************************************

* A-3322-163-A KEY BOARD, COMPLETE********************

< CONNECTOR >


< DIODE >

D806 8-719-032-86 LED SEL5420E (R•D•S)

< RESISTOR >

R819 1-249-427-11 CARBON 6.8K 5% 1/4WR820 1-247-843-11 CARBON 3.3K 5% 1/4WR821 1-249-420-11 CARBON 1.8K 5% 1/4WR822 1-249-418-11 CARBON 1.2K 5% 1/4WR823 1-249-416-11 CARBON 820 5% 1/4W

R824 1-249-415-11 CARBON 680 5% 1/4WR826 1-249-427-11 CARBON 6.8K 5% 1/4WR827 1-247-843-11 CARBON 3.3K 5% 1/4WR828 1-249-420-11 CARBON 1.8K 5% 1/4WR829 1-249-418-11 CARBON 1.2K 5% 1/4W

R830 1-249-416-11 CARBON 820 5% 1/4WR831 1-249-415-11 CARBON 680 5% 1/4WR833 1-249-432-11 CARBON 18K 5% 1/4WR834 1-249-432-11 CARBON 18K 5% 1/4WR838 1-249-432-11 CARBON 18K 5% 1/4W

< SWITCH >

S808 1-762-196-21 SWITCH, TACTILE (TUNING•TIME SET –)S809 1-762-196-21 SWITCH, TACTILE (STANDBY)S810 1-762-196-21 SWITCH, TACTILE (SUMMER)S811 1-762-196-21 SWITCH, TACTILE (CLOCK)S812 1-762-196-21 SWITCH, TACTILE (TIMER)

S813 1-762-196-21 SWITCH, TACTILE (BAND)

– 53 –


MAINMAIN

S814 1-762-196-21 SWITCH, TACTILE (SLEEP)S815 1-762-196-21 SWITCH, TACTILE (PRESET +)S816 1-762-196-21 SWITCH, TACTILE (PLAY MODE•MONO/ST ISS)S817 1-762-196-21 SWITCH, TACTILE (DSPL ENT MEM)S818 1-762-196-21 SWITCH, TACTILE (AMS/SEARCH +)

S819 1-762-196-21 SWITCH, TACTILE (AMS/SEARCH =)S820 1-762-196-21 SWITCH, TACTILE (^)S821 1-762-196-21 SWITCH, TACTILE (p)S822 1-762-196-21 SWITCH, TACTILE (TUNING•TIME SET +)S823 1-762-196-21 SWITCH, TACTILE (PRESET –)

S825 1-762-196-21 SWITCH, TACTILE (SOUND)S826 1-762-196-21 SWITCH, TACTILE (FUNCTION)

*************************************************************

* A-3322-170-A MAIN BOARD, COMPLETE*********************

7-685-646-11 SCREW +BVTP 3X8 TYPE2 N-S

< CAPACITOR >

C1 1-162-851-11 CERAMIC 0.1uF 16VC2 1-162-213-31 CERAMIC 39PF 5% 50VC3 1-162-282-31 CERAMIC 100PF 10% 50VC4 1-162-306-11 CERAMIC 0.01uF 30% 16VC5 1-162-219-31 CERAMIC 68PF 5% 50V

C6 1-162-306-11 CERAMIC 0.01uF 30% 16VC7 1-162-306-11 CERAMIC 0.01uF 30% 16VC8 1-162-851-11 CERAMIC 0.1uF 16VC9 1-162-306-11 CERAMIC 0.01uF 30% 16VC10 1-162-306-11 CERAMIC 0.01uF 30% 16V

C11 1-162-290-31 CERAMIC 470PF 10% 50V!C12 1-136-355-11 FILM 330PF 5% 100V

C13 1-162-201-31 CERAMIC 12PF 5% 50VC14 1-162-199-31 CERAMIC 10PF 5% 50VC16 1-162-851-11 CERAMIC 0.1uF 16V

C17 1-162-294-31 CERAMIC 0.001uF 10% 50VC18 1-162-290-31 CERAMIC 470PF 10% 50VC19 1-162-294-31 CERAMIC 0.001uF 10% 50VC20 1-162-306-11 CERAMIC 0.01uF 30% 16VC21 1-162-294-31 CERAMIC 0.001uF 10% 50V

C22 1-162-294-31 CERAMIC 0.001uF 10% 50VC23 1-162-199-31 CERAMIC 10PF 5% 50VC24 1-162-215-31 CERAMIC 47PF 5% 50VC25 1-126-233-11 ELECT 22uF 20% 50VC26 1-162-306-11 CERAMIC 0.01uF 30% 16V

C27 1-162-301-11 CERAMIC 0.0015uF 30% 16VC28 1-124-903-11 ELECT 1uF 20% 50VC29 1-162-851-11 CERAMIC 0.1uF 16VC30 1-124-907-11 ELECT 10uF 20% 50VC31 1-124-907-11 ELECT 10uF 20% 50V

C32 1-124-907-11 ELECT 10uF 20% 50VC33 1-130-485-00 MYLAR 0.015uF 5% 50VC34 1-130-485-00 MYLAR 0.015uF 5% 50VC35 1-162-306-11 CERAMIC 0.01uF 30% 16V

C36 1-124-472-11 ELECT 470uF 20% 10VC37 1-162-851-11 CERAMIC 0.1uF 16VC38 1-162-851-11 CERAMIC 0.1uF 16VC39 1-124-903-11 ELECT 1uF 20% 50VC40 1-124-907-11 ELECT 10uF 20% 50V

C41 1-162-288-31 CERAMIC 330PF 10% 50VC42 1-162-305-11 CERAMIC 0.0068uF 20% 16VC43 1-102-978-00 CERAMIC 220PF 5% 50VC44 1-162-306-11 CERAMIC 0.01uF 30% 16VC45 1-162-306-11 CERAMIC 0.01uF 30% 16V

C46 1-162-306-11 CERAMIC 0.01uF 30% 16VC47 1-162-851-11 CERAMIC 0.1uF 16VC48 1-162-211-31 CERAMIC 33PF 5% 50VC49 1-162-203-31 CERAMIC 15PF 5% 50VC50 1-161-494-00 CERAMIC 0.022uF 25V

C51 1-162-282-31 CERAMIC 100PF 10% 50VC52 1-162-306-11 CERAMIC 0.01uF 30% 16VC53 1-162-306-11 CERAMIC 0.01uF 30% 16VC54 1-162-306-11 CERAMIC 0.01uF 30% 16VC55 1-162-306-11 CERAMIC 0.01uF 30% 16V

C56 1-162-294-31 CERAMIC 0.001uF 10% 50VC57 1-162-294-31 CERAMIC 0.001uF 10% 50VC58 1-162-294-31 CERAMIC 0.001uF 10% 50VC59 1-162-294-31 CERAMIC 0.001uF 10% 50VC60 1-124-907-11 ELECT 10uF 20% 50V

C61 1-162-306-11 CERAMIC 0.01uF 30% 16VC62 1-162-306-11 CERAMIC 0.01uF 30% 16VC63 1-124-290-00 ELECT 47uF 20% 10VC64 1-162-306-11 CERAMIC 0.01uF 30% 16VC65 1-136-177-00 FILM 1uF 5% 50V

C68 1-126-961-11 ELECT 2.2uF 20% 50VC69 1-124-907-11 ELECT 10uF 20% 50VC70 1-161-494-00 CERAMIC 0.022uF 25VC71 1-162-291-31 CERAMIC 560PF 10% 50VC72 1-161-494-00 CERAMIC 0.022uF 25V

C73 1-126-961-11 ELECT 2.2uF 20% 50VC74 1-162-211-31 CERAMIC 33PF 5% 50VC75 1-162-211-31 CERAMIC 33PF 5% 50VC76 1-162-294-31 CERAMIC 0.001uF 10% 50VC77 1-162-288-31 CERAMIC 330PF 10% 50V

C78 1-162-291-31 CERAMIC 560PF 10% 50VC80 1-161-494-00 CERAMIC 0.022uF 25VC81 1-162-306-11 CERAMIC 0.01uF 30% 16VC101 1-130-473-00 MYLAR 0.0015uF 5% 50VC102 1-162-302-11 CERAMIC 0.0022uF 30% 16V

C103 1-104-664-11 ELECT 47uF 20% 10VC104 1-161-020-11 CERAMIC 0.039uF 10% 16VC105 1-124-902-00 ELECT 0.47uF 20% 50VC106 1-124-903-11 ELECT 1uF 20% 50VC107 1-124-902-00 ELECT 0.47uF 20% 50V

C108 1-130-495-00 MYLAR 0.1uF 5% 50VC109 1-130-487-00 MYLAR 0.022uF 5% 50VC110 1-162-306-11 CERAMIC 0.01uF 30% 16V

KEY


– 54 –


MAIN

C111 1-126-963-11 ELECT 4.7uF 20% 50VC112 1-124-903-11 ELECT 1uF 20% 50VC113 1-162-282-31 CERAMIC 100PF 10% 50VC115 1-124-443-00 ELECT 100uF 20% 10VC116 1-126-786-11 ELECT 47uF 20% 16V

C117 1-130-497-00 MYLAR 0.15uF 5% 50VC118 1-126-927-11 ELECT 2200uF 20% 10VC121 1-162-282-31 CERAMIC 100PF 10% 50VC123 1-124-907-11 ELECT 10uF 20% 50VC124 1-162-302-11 CERAMIC 0.0022uF 30% 16V

C125 1-162-294-31 CERAMIC 0.001uF 10% 50VC201 1-130-473-00 MYLAR 0.0015uF 5% 50VC202 1-162-302-11 CERAMIC 0.0022uF 30% 16VC203 1-104-664-11 ELECT 47uF 20% 10VC204 1-161-020-11 CERAMIC 0.039uF 10% 16V

C205 1-124-902-00 ELECT 0.47uF 20% 50VC206 1-124-903-11 ELECT 1uF 20% 50VC207 1-124-902-00 ELECT 0.47uF 20% 50VC208 1-130-495-00 MYLAR 0.1uF 5% 50VC209 1-130-487-00 MYLAR 0.022uF 5% 50V

C210 1-162-306-11 CERAMIC 0.01uF 30% 16VC211 1-126-963-11 ELECT 4.7uF 20% 50VC212 1-124-903-11 ELECT 1uF 20% 50VC213 1-162-282-31 CERAMIC 100PF 10% 50VC215 1-124-443-00 ELECT 100uF 20% 10V

C216 1-126-786-11 ELECT 47uF 20% 16VC217 1-130-497-00 MYLAR 0.15uF 5% 50VC218 1-126-927-11 ELECT 2200uF 20% 10VC221 1-162-282-31 CERAMIC 100PF 10% 50VC223 1-124-907-11 ELECT 10uF 20% 50V

C224 1-162-302-11 CERAMIC 0.0022uF 30% 16VC225 1-162-294-31 CERAMIC 0.001uF 10% 50VC301 1-124-443-00 ELECT 100uF 20% 10VC302 1-124-443-00 ELECT 100uF 20% 10VC303 1-126-233-11 ELECT 22uF 20% 50V

C304 1-104-664-11 ELECT 47uF 20% 10VC305 1-162-294-31 CERAMIC 0.001uF 10% 50VC307 1-104-666-11 ELECT 220uF 20% 10VC308 1-162-306-11 CERAMIC 0.01uF 30% 16VC309 1-162-306-11 CERAMIC 0.01uF 30% 16V

C310 1-124-443-00 ELECT 100uF 20% 10VC311 1-124-443-00 ELECT 100uF 20% 10VC312 1-104-664-11 ELECT 47uF 20% 10VC313 1-124-472-11 ELECT 470uF 20% 10VC314 1-162-851-11 CERAMIC 0.1uF 16V

C315 1-124-472-11 ELECT 470uF 20% 10VC316 1-162-306-11 CERAMIC 0.01uF 30% 16VC317 1-124-564-11 ELECT 4700uF 20% 25VC318 1-162-306-11 CERAMIC 0.01uF 30% 16VC319 1-124-907-11 ELECT 10uF 20% 50V

C320 1-104-664-11 ELECT 47uF 20% 25VC321 1-126-233-11 ELECT 22uF 20% 50VC322 1-162-284-31 CERAMIC 150PF 10% 50V

C323 1-124-907-11 ELECT 10uF 20% 50VC324 1-162-302-11 CERAMIC 0.0022uF 30% 16VC325 1-162-294-31 CERAMIC 0.001uF 10% 50VC326 1-124-902-00 ELECT 0.47uF 20% 50VC327 1-126-963-11 ELECT 4.7uF 20% 50V

C328 1-162-302-11 CERAMIC 0.0022uF 30% 16VC329 1-104-664-11 ELECT 47uF 20% 10VC330 1-162-306-11 CERAMIC 0.01uF 30% 16VC331 1-124-443-00 ELECT 100uF 20% 10VC332 1-130-481-00 MYLAR 0.0068uF 5% 50V

C334 1-130-471-00 MYLAR 0.001uF 5% 50VC335 1-130-471-00 MYLAR 0.001uF 5% 50VC336 1-124-907-11 ELECT 10uF 20% 50VC337 1-104-666-11 ELECT 220uF 20% 10VC338 1-124-907-11 ELECT 10uF 20% 50V

C339 1-124-907-11 ELECT 10uF 20% 50VC340 1-124-478-11 ELECT 100uF 20% 25VC341 1-126-963-11 ELECT 4.7uF 20% 50VC342 1-162-851-11 CERAMIC 0.1uF 16VC344 1-162-851-11 CERAMIC 0.1uF 16V

C345 1-162-294-31 CERAMIC 0.001uF 10% 50VC346 1-162-306-11 CERAMIC 0.01uF 30% 16VC351 1-162-294-31 CERAMIC 0.001uF 10% 50VC352 1-126-963-11 ELECT 4.7uF 20% 50VC353 1-126-963-11 ELECT 4.7uF 20% 50V

C354 1-162-306-11 CERAMIC 0.01uF 30% 16VC355 1-162-851-11 CERAMIC 0.1uF 16VC356 1-162-851-11 CERAMIC 0.1uF 16VC357 1-162-306-11 CERAMIC 0.01uF 30% 16VC358 1-124-903-11 ELECT 1uF 20% 50V

C359 1-104-664-11 ELECT 47uF 20% 10VC360 1-162-851-11 CERAMIC 0.1uF 16VC361 1-162-851-11 CERAMIC 0.1uF 16VC362 1-162-306-11 CERAMIC 0.01uF 30% 16VC363 1-124-472-11 ELECT 470uF 20% 10V

C364 1-161-494-00 CERAMIC 0.022uF 25V

< FILTER >

CF1 1-781-406-11 FILTER, CERAMICCF2 1-781-406-11 FILTER, CERAMICCF3 1-781-171-11 DISCRIMINATOR, CERAMIC

< ENCAPSULATED COMPONENT >

CFT1 1-233-885-11 ENCAPSULATED COMPONENT

< CONNECTOR >

CNP1 1-778-310-11 PLUG, CONNECTOR 2P (MW/LW)CNP2 1-694-215-11 TERMINAL BOARD (FM)

* CNP301 1-564-519-11 PLUG, CONNECTOR 4P* CNP302 1-580-165-11 PIN, CONNECTOR (PC BOARD) 4P

CNP303 1-695-346-21 PIN, CONNECTOR (PC BOARD) 23P


– 55 –


MAIN

* CNP305 1-564-506-11 PLUG, CONNECTOR 3P* CNP306 1-564-509-11 PLUG, CONNECTOR 6P* CNP307 1-564-508-11 PLUG, CONNECTOR 5P* CNP312 1-564-187-00 PIN, CONNECTOR

< TRIMMER >

CT1 1-141-459-11 CAP, TRIMMER (SEAL TYPE) 45PFCT2 1-141-486-11 CAP, ADJ 10PFCT3 1-141-459-11 CAP, TRIMMER (SEAL TYPE) 45PFCT4 1-141-411-11 CAP, ADJ 20PF

< DIODE >

D1 8-719-991-33 DIODE 1SS133T-77D2 8-719-991-33 DIODE 1SS133T-77D3 8-719-050-69 DIODE KV1520ND4 8-719-991-33 DIODE 1SS133T-77D5 8-719-991-33 DIODE 1SS133T-77

D6 8-719-991-33 DIODE 1SS133T-77D8 8-719-991-33 DIODE 1SS133T-77D9 8-719-991-33 DIODE 1SS133T-77D10 8-719-991-33 DIODE 1SS133T-77D301 8-719-991-33 DIODE 1SS133T-77

D302 8-719-991-33 DIODE 1SS133T-77D304 8-719-991-33 DIODE 1SS133T-77D305 8-719-991-33 DIODE 1SS133T-77D306 8-719-109-89 DIODE RD5.6ESB2D307 8-719-109-97 DIODE RD6.8ES-B2

D308 8-719-991-33 DIODE 1SS133T-77D310 8-719-921-40 DIODE MTZJ-4.7CD311 8-719-991-33 DIODE 1SS133T-77D312 8-719-109-97 DIODE RD6.8ES-B2

< IC >

IC1 8-759-644-86 IC TA2104BNIC2 8-759-549-77 IC BH2615SIC3 8-759-541-48 IC BU1924IC301 8-759-264-71 IC TA2068NIC302 8-759-540-49 IC BH3854AFS

IC303 8-759-426-51 IC BA5417

< TERMINAL BOARD >

* J301 1-537-240-41 TERMINAL BOARD (CHECKER PIN) (SPEAKER)

< COIL >

L1 1-410-521-11 INDUCTOR 100uHL2 1-408-599-31 INDUCTOR 4.7uHL3 1-416-785-11 COIL, MW ANTENNAL4 1-416-786-11 COIL, LW ANTENNAL5 1-411-199-31 COIL, MW/LW OSC

L6 1-410-509-11 INDUCTOR 10uHL7 1-410-521-11 INDUCTOR 100uHL8 1-408-599-31 INDUCTOR 4.7uHL9 1-410-089-11 INDUCTOR 15mH

L10 1-410-525-11 INDUCTOR 220uHL11 1-410-521-11 INDUCTOR 100uHL12 1-410-521-11 INDUCTOR 100uHL13 1-410-521-11 INDUCTOR 100uHL14 1-414-142-11 INDUCTOR 1uH

L15 1-233-306-31 ENCAPSULATED COMPONENTL102 1-410-397-21 INDUCTOR 1.1uHL103 1-409-932-11 COIL, AIR-COREL202 1-410-397-21 INDUCTOR 1.1uHL203 1-409-932-11 COIL, AIR-CORE

L302 1-412-045-11 INDUCTOR 2.2mH

< TRANSISTOR >

Q1 8-729-119-32 FET 2SK193Q2 8-729-922-66 TRANSISTOR 2SC2410SNQ3 8-729-905-50 TRANSISTOR DTC343TSQ4 8-729-178-62 TRANSISTOR 2SC2786-LQ5 8-729-922-66 TRANSISTOR 2SC2410SN

Q6 8-729-902-80 TRANSISTOR DTA114YSQ7 8-729-902-80 TRANSISTOR DTA114YSQ9 8-729-922-66 TRANSISTOR 2SC2410SNQ10 8-729-902-80 TRANSISTOR DTA114YSQ11 8-729-029-72 TRANSISTOR DTC114YSA

Q12 8-729-029-72 TRANSISTOR DTC114YSAQ13 8-729-029-72 TRANSISTOR DTC114YSAQ14 8-729-029-72 TRANSISTOR DTC114YSAQ15 8-729-902-80 TRANSISTOR DTA114YSQ16 8-729-012-83 FET 2SK679A

Q17 8-729-106-07 FET 2SK514-HQ18 8-729-119-32 FET 2SK193Q19 8-729-029-72 TRANSISTOR DTC114YSAQ20 8-729-029-72 TRANSISTOR DTC114YSAQ21 8-729-902-80 TRANSISTOR DTA114YS

Q22 8-729-905-50 TRANSISTOR DTC343TSQ301 8-729-902-80 TRANSISTOR DTA114YSQ302 8-729-029-94 TRANSISTOR DTC143TSAQ303 8-729-281-53 TRANSISTOR 2SC1815-GRQ304 8-729-230-45 TRANSISTOR 2SC2458-YGR

Q305 8-729-230-45 TRANSISTOR 2SC2458-YGRQ306 8-729-195-23 TRANSISTOR 2SA952Q307 8-729-195-23 TRANSISTOR 2SA952Q308 8-729-021-82 TRANSISTOR 2SD2396KQ309 8-729-230-45 TRANSISTOR 2SC2458-YGR

Q310 8-729-141-83 TRANSISTOR 2SB1094-LKQ311 8-729-902-80 TRANSISTOR DTA114YSQ312 8-729-902-80 TRANSISTOR DTA114YSQ313 8-729-230-45 TRANSISTOR 2SC2458-YGRQ314 8-729-200-39 TRANSISTOR 2SC2236-Y

< RESISTOR >

R1 1-249-422-11 CARBON 2.7K 5% 1/4WR2 1-249-425-11 CARBON 4.7K 5% 1/4WR3 1-249-425-11 CARBON 4.7K 5% 1/4W

– 56 –


MAIN

R4 1-249-425-11 CARBON 4.7K 5% 1/4WR5 1-249-425-11 CARBON 4.7K 5% 1/4WR6 1-249-426-11 CARBON 5.6K 5% 1/4WR7 1-247-887-00 CARBON 220K 5% 1/4WR8 1-247-887-00 CARBON 220K 5% 1/4W

R9 1-249-425-11 CARBON 4.7K 5% 1/4WR10 1-249-429-11 CARBON 10K 5% 1/4WR11 1-249-403-11 CARBON 68 5% 1/4WR13 1-249-417-11 CARBON 1K 5% 1/4WR14 1-249-411-11 CARBON 330 5% 1/4W

R15 1-249-417-11 CARBON 1K 5% 1/4WR16 1-247-791-00 CARBON 22 5% 1/4WR17 1-249-419-11 CARBON 1.5K 5% 1/4WR18 1-249-437-11 CARBON 47K 5% 1/4WR19 1-249-411-11 CARBON 330 5% 1/4W

R20 1-249-429-11 CARBON 10K 5% 1/4WR21 1-249-429-11 CARBON 10K 5% 1/4WR22 1-249-424-11 CARBON 3.9K 5% 1/4WR23 1-249-429-11 CARBON 10K 5% 1/4WR24 1-249-424-11 CARBON 3.9K 5% 1/4W

R25 1-247-843-11 CARBON 3.3K 5% 1/4WR26 1-249-421-11 CARBON 2.2K 5% 1/4WR27 1-249-406-11 CARBON 120 5% 1/4WR28 1-249-429-11 CARBON 10K 5% 1/4WR29 1-249-429-11 CARBON 10K 5% 1/4W


R35 1-249-429-11 CARBON 10K 5% 1/4WR36 1-249-429-11 CARBON 10K 5% 1/4WR37 1-249-426-11 CARBON 5.6K 5% 1/4WR38 1-249-437-11 CARBON 47K 5% 1/4WR39 1-249-412-11 CARBON 390 5% 1/4W

R40 1-249-415-11 CARBON 680 5% 1/4WR41 1-249-417-11 CARBON 1K 5% 1/4WR42 1-247-843-11 CARBON 3.3K 5% 1/4WR43 1-249-421-11 CARBON 2.2K 5% 1/4WR44 1-249-417-11 CARBON 1K 5% 1/4W

R45 1-247-843-11 CARBON 3.3K 5% 1/4WR46 1-249-417-11 CARBON 1K 5% 1/4WR47 1-249-417-11 CARBON 1K 5% 1/4WR48 1-249-421-11 CARBON 2.2K 5% 1/4WR49 1-249-421-11 CARBON 2.2K 5% 1/4W

R50 1-249-441-11 CARBON 100K 5% 1/4WR51 1-249-437-11 CARBON 47K 5% 1/4WR52 1-249-437-11 CARBON 47K 5% 1/4WR53 1-247-863-00 CARBON 22K 5% 1/4WR54 1-249-404-00 CARBON 82 5% 1/4W

R101 1-249-431-11 CARBON 15K 5% 1/4WR102 1-249-404-00 CARBON 82 5% 1/4WR103 1-247-881-00 CARBON 120K 5% 1/4W

R104 1-247-843-11 CARBON 3.3K 5% 1/4WR105 1-247-815-00 CARBON 220 5% 1/4WR107 1-249-431-11 CARBON 15K 5% 1/4WR108 1-249-421-11 CARBON 2.2K 5% 1/4WR109 1-249-417-11 CARBON 1K 5% 1/4W

R110 1-249-414-11 CARBON 560 5% 1/4WR111 1-249-425-11 CARBON 4.7K 5% 1/4WR112 1-249-426-11 CARBON 5.6K 5% 1/4WR113 1-249-431-11 CARBON 15K 5% 1/4WR114 1-249-417-11 CARBON 1K 5% 1/4W

R115 1-249-406-11 CARBON 120 5% 1/4WR119 1-249-385-11 CARBON 2.2 5% 1/6WR121 1-249-437-11 CARBON 47K 5% 1/4WR201 1-249-431-11 CARBON 15K 5% 1/4WR202 1-249-404-00 CARBON 82 5% 1/4W

R203 1-247-881-00 CARBON 120K 5% 1/4WR204 1-247-843-11 CARBON 3.3K 5% 1/4WR205 1-247-815-00 CARBON 220 5% 1/4WR207 1-249-431-11 CARBON 15K 5% 1/4WR208 1-249-421-11 CARBON 2.2K 5% 1/4W

R209 1-249-417-11 CARBON 1K 5% 1/4WR210 1-249-414-11 CARBON 560 5% 1/4WR211 1-249-425-11 CARBON 4.7K 5% 1/4WR212 1-249-426-11 CARBON 5.6K 5% 1/4WR213 1-249-431-11 CARBON 15K 5% 1/4W

R214 1-249-417-11 CARBON 1K 5% 1/4WR215 1-249-406-11 CARBON 120 5% 1/4WR218 1-249-404-00 CARBON 82 5% 1/4WR219 1-249-385-11 CARBON 2.2 5% 1/6WR221 1-249-437-11 CARBON 47K 5% 1/4W

R301 1-247-903-00 CARBON 1M 5% 1/4WR302 1-249-399-11 CARBON 33 5% 1/4WR303 1-249-429-11 CARBON 10K 5% 1/4WR304 1-249-417-11 CARBON 1K 5% 1/4WR305 1-249-403-11 CARBON 68 5% 1/4W

R306 1-249-435-11 CARBON 33K 5% 1/4WR307 1-249-389-11 CARBON 4.7 5% 1/4WR308 1-249-429-11 CARBON 10K 5% 1/4WR309 1-249-401-11 CARBON 47 5% 1/4WR310 1-249-404-00 CARBON 82 5% 1/4W

R311 1-249-419-11 CARBON 1.5K 5% 1/4WR312 1-249-429-11 CARBON 10K 5% 1/4WR313 1-249-437-11 CARBON 47K 5% 1/4WR314 1-249-437-11 CARBON 47K 5% 1/4WR315 1-260-078-11 CARBON 18 5% 1/2W

R316 1-249-410-11 CARBON 270 5% 1/4WR318 1-260-076-11 CARBON 10 5% 1/2WR319 1-249-420-11 CARBON 1.8K 5% 1/4WR320 1-249-429-11 CARBON 10K 5% 1/4WR321 1-249-432-11 CARBON 18K 5% 1/4W

R322 1-249-425-11 CARBON 4.7K 5% 1/4WR323 1-247-903-00 CARBON 1M 5% 1/4WR324 1-247-807-11 CARBON 100 5% 1/4W

– 57 –



REC SW


R331 1-249-427-11 CARBON 6.8K 5% 1/4WR333 1-249-427-11 CARBON 6.8K 5% 1/4WR334 1-249-441-11 CARBON 100K 5% 1/4WR335 1-249-441-11 CARBON 100K 5% 1/4WR336 1-249-429-11 CARBON 10K 5% 1/4W

R337 1-249-439-11 CARBON 68K 5% 1/4WR338 1-249-425-11 CARBON 4.7K 5% 1/4WR339 1-249-429-11 CARBON 10K 5% 1/4WR341 1-247-807-11 CARBON 100 5% 1/4WR342 1-247-899-11 CARBON 680K 5% 1/4W

R343 1-249-418-11 CARBON 1.2K 5% 1/4WR345 1-249-404-00 CARBON 82 5% 1/4WR346 1-247-807-11 CARBON 100 5% 1/4WR348 1-260-064-11 CARBON 1 5% 1/2WR349 1-249-431-11 CARBON 15K 5% 1/4W

R350 1-249-421-11 CARBON 2.2K 5% 1/4WR351 1-249-421-11 CARBON 2.2K 5% 1/4W

< SWITCH >

S824 1-762-871-11 SWITCH, KEY BOARD (RESET)

< TRANSFORMER >

T301 1-433-268-00 TRANSFORMER, BIAS OSCILLATOR

< TUNER >

* TU1 1-693-378-11 TUNER UNIT

< VIBRATOR >

X1 1-760-130-11 VIBRATOR, CRYSTAL (75kHz)X2 1-579-900-21 VIBRATOR, CRYSTAL (4.332MHz)

*************************************************************

* 1-674-304-11 POWER BOARD*************

1-533-217-31 HOLDER, FUSE

< CAPACITOR >

C901 1-164-159-21 CERAMIC 0.1uF 50VC902 1-164-159-21 CERAMIC 0.1uF 50VC903 1-164-159-21 CERAMIC 0.1uF 50VC904 1-164-159-21 CERAMIC 0.1uF 50VC905 1-164-159-21 CERAMIC 0.1uF 50V

C906 1-124-564-11 ELECT 4700uF 20% 25V

< CONNECTOR >

* CNP901 1-564-518-11 PLUG, CONNECTOR 3P* CNP902 1-580-230-31 PIN, CONNECTOR (PC BOARD) 2P

< DIODE >

D901 8-719-902-17 DIODE U15GD902 8-719-902-17 DIODE U15GD903 8-719-902-17 DIODE U15GD904 8-719-902-17 DIODE U15GD905 8-719-991-33 DIODE 1SS133T-77

< FUSE >

!F901 1-532-500-31 FUSE, TIME-LAG (T630mAL/250V)!F902 1-532-465-31 FUSE, TIME-LAG (T3.15AL/250V)

< RESISTOR >

R901 1-247-815-00 CARBON 220 5% 1/4W

< TRANSFORMER >

!T901 1-431-972-11 TRANSFORMER, POWER*************************************************************

* 1-674-298-11 REC SW BOARD*************

< CONNECTOR >


< SWITCH >

SW301 1-762-565-11 SWITCH, SLIDE (REC/PB)*************************************************************

MISCELLANEOUS***************

!3 1-575-651-21 CORD, POWER62 1-791-980-11 CABLE, FFC 23P103 1-452-732-11 MAGNET112 1-769-824-11 WIRE (FLAT TYPE) (16 CORE)!353 8-848-483-05 PICK-UP, OPTICAL KSS-213C

355 X-2626-202-1 CHASSIS ASSY (MB), MOTOR (SPINDLE)(INCLUDING M701)

HE301 1-543-876-11 HEAD (ERASE)HRP301 1-543-964-12 HEAD, MAGNETIC (RECORD/PLAYBACK)M301 X-3365-538-1 MOTOR ASSY (CAPSTAN/REEL)M702 X-2625-769-1 GEAR ASSY (MB) (RP), MOTOR (SLED)

S301 1-571-556-11 SWITCH, LEAF (MD POWER)S302 1-571-556-11 SWITCH, LEAF (MD PLAY)SP301 1-505-395-21 SPEAKER (10cm) (L-CH)SP302 1-505-395-21 SPEAKER (10cm) (R-CH)SW701 1-692-960-11 SWITCH, PUSH (1 KEY) (CD DOOR)

*************************************************************

POWERMAIN

– 58 –

Sony CorporationPersonal Audio Company9-927-150-11 99G0451-1

Printed in Japan C1999. 7Published by General Engineering Dept.

PMC-R30L

ACCESSORIES & PACKING MATERIALS********************************

1-501-594-11 ANTENNA (FM)1-754-034-11 ANTENNA, LOOP (MW/LW)3-027-153-11 LID, BATTERY CASE (FOR RMT-C107AD)

* 3-704-285-01 BAG (STANDARD), PROTECTION3-867-445-11 MANUAL, INSTRUCTION (ENGLISH,SPANISH)

(AEP,UK)

3-867-445-21 MANUAL, INSTRUCTION (FRENCH,GERMAN)(AEP)

3-867-445-31 MANUAL, INSTRUCTION (DUTCH,PORTUGUESE)(AEP)

3-867-445-41 MANUAL, INSTRUCTION (ITALIAN) (IT)3-867-445-51 MANUAL, INSTRUCTION (SWEDISH,FINNISH)

(CET)3-867-445-61 MANUAL, INSTRUCTION (POLISH,CZECH,

HUNGARIAN) (CET)

A-3250-959-A REMOTE COMMANDER RMT-C107AD*************************************************************

**************HARDWARE LIST**************

#1 7-685-647-79 SCREW +BVTP 3X10 TYPE2 N-S#2 7-685-646-11 SCREW +BVTP 3X8 TYPE2 N-S#3 7-685-663-71 SCREW +BVTP 4X16 TYPE2 N-S#4 7-685-649-79 SCREW +BVTP 3X14 TYPE2 N-S#5 7-685-860-04 SCREW +BVTT 2.6X4 (S)

#6 7-685-792-09 SCREW +PTT 2.6X6 (S)#7 7-685-851-04 SCREW +BVTT 2X4 (S)#8 7-685-861-01 SCREW +BVTT 2.6X5 (S)#9 7-685-781-09 SCREW +PTT 2X4 (S)#10 7-685-104-19 SCREW +P 2X6 TYPE2 NON-SLIT

#11 7-685-648-79 SCREW +BVTP 3X12 TYPE2 N-S#12 7-628-254-05 SCREW +PS 2.6X5


Page INCORRECT CORRECT

PMC-R30L

CORRECTION-1Correct your service manual as shown below.

AEP ModelUK Model

SERVICE MANUAL

• EXPLODED VIEWS!, _: indicates corrected portion.

40

Ver 1.0 1999. 06

(RPC-00004)

102 3-025-505-01 CD LID104 3-021-020-01 PLATE, CHUCKING105 3-026-314-01 BRACKET (LIFT)109 3-025-504-01 CABINET (UPPER)

3-025-505-31 CD LID3-019-395-01 PLATE, CHUCKING3-026-314-11 BRACKET (LIFT)3-025-504-11 CABINET (UPPER)

42

7 3-042-214-01 CABINET (REAR)0T901 1-431-972-11 TRANSFORMER, POWER

#14

Part No. Description Remark

3-039-611-01 CABINET (REAR)0 1-435-182-11 TRANSFORMER, POWER

7-685-134-19 SCREW +P 2.6X8 TYPE2 SLIT


4

2

7

5

6

#3

#14

#2

#2

IC303

Q308

T901

F901

F902

not supplied

notsupplied

#4

%

!

$

48 402 3-025-513-01 CABINET, SPEAKER (FRONT)404 3-025-514-01 CABINET, SPEAKER (REAR)

3-046-188-01 CABINET, SPEAKER (FRONT)3-025-514-11 CABINET, SPEAKER (REAR)

57 0T901 1-431-972-11 TRANSFORMER, POWER 0 1-435-182-11 TRANSFORMER, POWER

The components identified bymark 0 or dotted line with mark0 are critical for safety.Replace only with part numberspecified.

– 2 –

Sony CorporationAudio Entertainment Group

2000D0451-1DPrinted in Japan ©2000. 4

Published by HA Quality Assurance Dept.

9-927-150-91

52 3-042-215-01 COVER (FRONT)55 3-025-499-01 HOLDER, CASSETTE58 3-039-911-01 LENS, RDS65 3-025-508-01 BUTTON (REC)66 3-025-511-01 BUTTON (PLAY)

67 3-025-510-01 BUTTON (REW)68 3-025-509-01 BUTTON (FF)69 3-025-512-01 BUTTON (STOP)70 3-025-507-01 BUTTON (PAUSE)71 3-042-216-01 CABINET (FRONT)

72 3-039-915-01 LENS (RDS HOLDER)74 not supplied

Page INCORRECT CORRECT

41

Ref. No. Part No. Description Remark Part No. Description Remark

not supplied (supplied with 71)3-025-499-11 HOLDER, CASSETTE

not supplied (supplied with 71)3-025-508-11 BUTTON (REC)3-025-511-11 BUTTON (PLAY)

3-025-510-11 BUTTON (REW)3-025-509-11 BUTTON (FF)3-025-512-11 BUTTON (STOP)3-025-507-11 BUTTON (PAUSE)X-3378-057-1 CABINET (FRONT) SUB ASSY

not supplied3-039-909-01 KNOB (SNOOZE)

#2

#2

#2

#2

#1

#1

#2

#1

#5

#5

#2

#2

#1

LCD801

not supplied

D804

not supplied

not supplied

not supplied

MF-107

54

55

56

65

64

51

74

63

62

59

57

6061

53

71

6667

6869 70

73

!

!

##### #

%

^

Documents

Sony Compact Data Sheet