ROAD SAFETYPRODUCTS

Randgate Consultants Pty LtdCollege House, 26 Peter Place Road, Bryanston 2021

T: 011 540 0332www.randgate.co.za

2m long x 1m highinterlocking road water

barriers

WATERFILLED

BARRIERS

SPEEDRAMPS

This popular water filled barrier has been used at road construction and building sites as a vehicle barrier for the past decade. The Barrier is a great alternative to concrete barriers, no cranes or fork-lifts are required.

This mobile road safety barrier provides protection for road workers at work on construction or maintenance sites. The barrier has been proven as an effective method to separate traffic lanes, marking of detours and temporary routes.

• Placement by manual labour, no forklifts or cranes needed.

• Barriers connect by slight lifting and sliding

• Barriers may be filled with water or sand

• Water can be drained on site

• The 1 meter high barrier cordon off a 2 meter area - Setting up does not require specialized equipment

Features:

• Effective speed reducer

• Encourages traffic to reduce speed

• High visibility black and yellow ramps with reflector cats eyes for night

• Durable and manufactured to withstand high traffic volumes

• Low maintenance, tough recycled thermoplastic material

• Not recommended to be installed directly onto asphalt

• 2 Units per meter

IDEAL FOR:

Road works

Construction sites

Events

Redirection of traffic

Cordon off restricted areas

Safeguard of workers on sites

IDEAL FOR:

Residential and

Commercial

applications

including

multi-level

parkades

GUARD RAILS Galvanised Steel

Guard barrier

is the security

fence used in

highway, bridge

and road sides.

TRAFFICCONES

DELINEATORS

Traffic cones are

usually used to

divert traffic.

The reflective

sleeves are

for night time

visibility.

Our Delineators

are manufactured

to withstand

extreme hot or

cold conditions

thus providing

longer life.

• Reboundable Delineators • Interlocking Reboundable Lane Dividers

• Standard Delineators • Plastic Bases • Rubber Bases

PEDISTRIANBARRIERS

Erecting pedestrian barriers can be necessary to keep members of the

public safe from the hazards that may be

present.

Our pedestrian barriers are designed with safety

as a top priority.

Sturdy weighted feet and bright colours are

calculated to effectively shield the public from danger and increase

visibility.

All panels can be linked to enclose areas of all

shapes and sizes.

TRUCKING COMPONENTS

RANGE

TRUCK LICENCE HOLDERS

OMEGA CLAMP

CORNER PROTECTOR

MUD FLAP

INTERLOCKING FLOOR MATS

MUD GUARD

FIRE EXTINGUISHERCASING

CHOCKS

Randgate Consultants Pty LtdCollege House, 26 Peter Place Road, Bryanston 2021

T: 011 540 0332www.randgate.co.za

MODURAIL600 / 800

WEGARAIL SYSTEMS

REBOUNDABLE

DELINEATOR

AND STEP-UP

BASES

Both systems have the same structure and are in particular of the same static fixture with anchored base plates.

The impact forces are mainly derived by the two lower box beams in vertical and horizontal direction.

MODURAIL is

used on highways,

bridges and road

sides

IDEAL FOR:

Roadside, central reservations,

dividing strips, median crossings, bridges, in front of bridge piers and in

curves.

Advantages of the Wegarail systems:

• All containment levels from N2 to H4b covered.

• All operating widths from W2 to W8 covered.

• Uniform system height of 70 or 90cm.

• Double –beam design preventing over – or under riding.

• Modular structure consisting of only two,

three or four standard components.

• Easy installation and repair.

• Highly cost effective.

• Extensive compatibility.

Voted Best Delineator Worldwide:

• Two-part vertical marker.

• Top section made of blow-moulded high impact plastic (HDPE).

• Rebounding support from double walled flex boot, detachable.

• Restores to upright position, if struck by vehicle.

• Recessed sheeting area.

• Sloped sheeting, on one side or on both sides.

• Sheeting type 2, HIG.

• Handle on top.

• Available on 7, 16 and 28kg base

I – VMS BOARDS

&MOBILETRAILERBOARDS

I-VMS Full Matrix is a versatile light-weight advanced variable message warning sign (VMS), designed for Incident Support Units, W-way Patrolling Units, Emergency Crews and Maintenance Contractors. The unit can be deployed on the move, at reasonable speed allowing warning signs or directional arrows to be displayed immediately, when the emergency arises, in order to warn motorists of accidents and other dangers on the roads, and to provide clear instructions to traffic.

The Horizont Klemmfix Halogen Progressive Light system, with the warning lights of the class L8G, of the European Standard EN 12352, is the ideal solution. The sequential light systems of Horizont Klemmfix, either in halogen or in xenon electronic flash, are well-known for years, for their perfect directional lights RS 2000 and the reliability of their compact controls. The lamps are crash proof.

Mobile advance direction boards for motorways and other dual carriageways. Due to the active performance of the traffic signs, supported by two high intensity warning lights top left and right, motorists pay full attention on danger spots ahead. This VMS-Trailer can be used for many different applications and can be programmed according to individual needs. The basic version is pre-programmed with a selection of standard road signs and guiding arrow signs which meet almost all traffic situations. All signs are displayed by high intensity LEDs, bright and clearly visible. Signs and messages can easily be selected via GMS or Computer Connector.

• Sequential light or synchronized blockage.

• The height of the light can be elevated up to 95 cm.

• Identical lamps, to be placed at any position within a line of lamps.

• Telescopic pole in red/white colour.

• Electronic xenon flash light.

• High light intensity.

• Small steady background light can be activated via flip switch.

• Four fold-out and pull-out feet.

• Deep dish- and overcharge protection.

• Charging also from vehicles, 12/24 V.

TELEBLITZ / SYNCHRON

GUIDECURB

SYSTEM

WARNMAXMOBILE

DELINEATOR

TRAFFIC ACCOMMODATION

TRAILER

• The single separator units are connected.

• Can be used temporarily or permanently.

• The stable, but flexible connection guarantees enough clearance in order to setup different curves.

• The manifold anti-skid system on the bottom of each unit ensures an excellent laying stability on the road surface. It can be easily exchanged after abrasion.

• The Guide Curb separator does not have to be glued or screwed to the road.

• In the contrary to road studs or road marking tapes, no residuals of glue are left on the lane. This avoids the danger of so called phantom markings.

• Lateral climbing edges allow vehicles firstly to climb on-and secondly to press down the separator whilst driving over. This aids position stability to the separator.

• Quick to deploy unit, ideal for emergency situations to indicate emergencies, fire or police presence or to mark an incident site.

• Sheeted one side or two sides.

• Sloped sheeting.

• Folds flat, so it’s easy to stack, carry and store.

• Use indoors or out to keep people out of areas that are off-limits.

• Indication, guidance, protection, No Waiting, just to name a few applications not only in public traffic, but also around shopping malls, hotels or in private areas.

• With its steady and solid base, the Warnmax can be quickly set up and cares for clear conditions due to its individual marking possibilities.

All traffic accommodation trailers comes fully equipped with the following:

• Two way radios.

• On board battery pack.

• Solar panels to charge batteries.

• Ablution Facilities.

• Light post with flood light.

• Operators will be trained.

• Operating and training manual supplied.

• Safety barrier suggested to be Modurail.

• Installed to protect Flagman / Operator and Trailler Equipment.

Stop and go systems are an essential part of keeping motorists safe. This can be achieved by manual stop and go or electronic robot trailer systems. In addition to providing safe passage for traffic through the Work Zone, effective traffic accommodation involves minimizing inconvenience to traffic. To ensure traffic moves effectively through the Work Zone, it is critical that the Traffic Control Devices (TCD’s) used to advise, warn and direct traffic are appropriate for the site conditions.

ECONO DELINEATOR WITH BASE

WITH HALOGEN

LAMPS

EUROBLITZIDEAL FOR

POLICE AND EMERGENCY SERVICES

CRASHSAFE

BARRIERPROSEC

90

Randgate Consultants Pty LtdCollege House, 26 Peter Place Road, Bryanston 2021

T: 011 540 0332www.randgate.co.za

• Delineator Blades 600 x 150 / 800 x 200 / 1000 x 250.

• All blade types hard and soft plastic extraction.

• Can be single or Double side.• Double side blades can be Point to Point

or Opposite Direction.• Base made from recycled rubber / plastic.

WARNING LIGHTS• Crash proof halogen lamps.• Power supply 12 V or 230 V.

• In case of a break from the mains, the system switches over automatically to 12 V, if a battery connected.

• A static back light is added during night.

• Discharge protection for rechargeable batteries.

• The direction of the traffic-guiding light can be changed easily and quickly via a rotary switch.

• 1-10 directional lamps RS 2000 halogen.

WARNING LIGHTS• Electronic xenon flash light• Uni- / bi-directional• High luminosity• Static backlight• Four fold-out feet• Deep battery discharge and overcharge protection for

rechargeable batteries• Charging also from vehicles, 12 / 24 V• Incl. adapter for plug-on to folding signs• 60 flashes/minute• 2 joule flash energy• Sequential light system• Identical lamps, to be placed at any position within a

line of lamps

Used as a mobile

wall for the

separation of

opposite traffic

flow and to protect

workmen in the

work zone.