Upload
winka
View
16
Download
0
Embed Size (px)
DESCRIPTION
Procedures as a productivity and safety tool Jean-Yves Fiset, Eng., Ph. D. [email protected]. Outline. Why bother? What is in a procedure What procedures can do for you Issues and tips A case study: abnormal situation management Resources. Why Bother?. - PowerPoint PPT Presentation
Citation preview
Outline
2
• Why bother?
• What is in a procedure
• What procedures can do for you
• Issues and tips
• A case study: abnormal situation management
• Resources
Why Bother?
3
In Preliminary Findings, CSB Investigators Report Bayer CropScience Explosion Was Caused by Runaway Chemical Reaction; Cite Significant Lapses in Process Safety, Outdated Operating Procedures
http://www.csb.gov/newsroom/detail.aspx?nid=238&SID=0&pg=3%2f%2f%2f%2f'%2c%2f%2f%2f'%2c%2f%2f'%2c%2f'%2c'%2c&print=y
Human Performance Analysis of Industrial Radiography Radiation Exposure Events http://www.osti.gov/bridge/servlets/purl/147724-h3ucf2/webviewable/147724.pdf
What is in a Procedure
4
• « A set of instructions to assist specified users in carrying out specified task in a specified context of use to achieve specified results »
ChecklistsOperating manuals« Cardex »ProceduresProtocols
Usually include•Pre- or entry conditions•Steps•Actions, decisions….•Specification of order of execution for none, some or all of the steps•Warnings and cautions•Post-conditions•« Configuration management »
What procedures can do for you
5
• For the individual – Support decision-making in stressful situations– Prevent or mitigate memory lapses– Document what was done
• For the organization– Train new staff – Refresh experienced staff on infrequent tasks– Support continuity planning– Manage events
Frequent Issues
6
• Using them
• Producing them
• Complying with them
CAP 716 AVIATION MAINTENANCE HUMAN FACTORS
Tips
7
• Strategy: define– Purpose of the procedures
• Help the organization achieve its purpose OR satisfy some external body OR both OR…
– Compliance policy (including how to handle deviations)
• E.g., Procedures shall be used as written and no deviation shall be tolerated… OR…. Procedures as guides… OR…several classes…
– How compliance will be assessed– How the procedures will be maintained
Tips
8
• Writing good procedures is tough but gets easier with a bit of practice– Experts at
the job are not necessarily great procedure writers
IOWA DEPARTMENT OF PUBLIC HEALTH - INDUSTRIAL RADIOGRAPHYEXPOSURE DEVICES REGULATORY GUIDEhttp://www.idph.state.ia.us/eh/common/pdf/radiological_health/industrialrad99.PDF
Common mistake
Tips
9
• Tactics– Specify for whom you write (or review) procedures and the
purpose of the procedure– Differentiate between « conceptual » and « procedural »
information AND organize both adequately– The process is: analyze the needs and constraints, produce
a first version, assess, and correct => repeat as required => then deploy and train
– Writer’s guide• Process for authoring, reviewing and authorizing• Authorized words• Fonts, styles, headings• Syntax• Principles and rules• Templates for pages and for procedures
Tips
10
• Ensure the text is legible– For text, avoid color like
the plague– Typically, you should
specify font size and « type » (e.g., Times Roman). Actual size depends on:
• Distance of use• Environment of use• Characteristics of users
(e.g., age…)• To be safe, may want to
specify larger sizes
Adapted from: http://www.visualexpert.com/Resources/olderdrivers.html,
20 years old 60 years old 75 years old
Sizes should be calculated and
measured on paper – avoid relying on
« points »
Tips
11
• Writing individual steps– Keep individual steps simple
• In general: short words in short sentences work best• One instruction by step
– Break down complex steps into simpler, successive steps
– Avoid negative in conditionals like a major plague• Try it:
– IF pressure in Tank 23 is NOT greater than 145 KPa, THEN Observe
– Use right format• steps for instructions, warnings for warnings, and notes for
notes!– Warnings before a step, not after….
– Check boxes or room for initials if each step is to be confirmed
Tips
12
• Use the right vocabulary– Always the same word for the same thing
• Few words => fewer mistakes• Words familiar to the staff AND correct for the task• Short words => easier and faster to read• Standardized rules for abreviations
– Use same abreviations throughout
Tips
13
– Rules for numbers • Usually, numeral for physical measures and for 11
items or more• Use separations = 277 733 rather than 2877733• Same form• Only the precision required and available• Include units of measure, where applicable• Avoid calculations like the plague
– If absolutely required, provide a calculation aid and enforce its use
• Use ranges => 17 – 23 C rather than 20 ± 3 C
Tips
14
• Level of detail– Making the procedure overly detailed does not
help any– Revisions often tend to increase the thickness of
the procedure while decreasing its usefulness…
Training
Level of Detail
For the Procedure
Familiarity
Tips
15
• Use good syntax– Active form rather than passive– Avoid inversions
• Longer to read• Higher error rate
– In a step, force sequences only when absolutely necessary
1. Do……2. Do….3. Do….
Sequence forced: ordered list
• Do……• Do….• Do….
a) Do……b) Do….c) Do….
Sequence not forced: unordered list
Common mistake
Tips
16
• Putting it all together– Review and
critique– Identify
improvements• Beware of
limits of knowledge on application
Warning?
Tips
17
• Some unanswered questions– Pictures? No pictures?– Prose or flowcharts?– Enough, too much, not enough information?
• Solution: combine training and procedure content, and take into account user knowledge before specifying the level of details
– Standards• Some process / attribute standards exist for
some types of user documentation
Tips
18
• A few cheap tricks…– The value of pre-testing…
• People will often spend more time explaining why they don’t think it is necessary to validate, walkdown or otherwise test the procedure than it would take to actually do it…
• Testing or validating a procedure solely by talking about it around a table is a weak method
– You will not get it right the first time• If you do, send your résumé…
– Procedures need to be maintained – A desktop review based on the rules and
principles presented here will reveal lots• Compliance with writer’s guide or good practices• Eliminating words without loosing the meaning• Procedural vs conceptual knowledge• ...
Common mystery
Case Study
• Abnormal Situation Management (ASM)
19
Case Study
• ASM
20
Case Study
• ASM: a procedure-driven approach
21
Resources
22
• Wieringa, D., Moore, C., Barnes, V., PROCEDURE WRITING: PRINCIPLES AND PRACTICES, 1998. 2nd ed. Columbus, OH: Battelle Press. [ISBN 1-57477-052-7. 243 pages, including index
• For the ASM case study: White Paper - Human Performance and Abnormal Situation Management– Paper copies are available– Can be downloaded from
• www.shumac.qc.ca or • www.shumac.com.ar
Conclusion
23
• Procedures are more than « words on paper »• They are not a necessary evil…
– they will help us to …. prevent a situation… respond to a situation… train staff… document our work…
• One of the most cost-effective way to improve operations and safety
• And, best of all, they can be developed and used by mere mortals
Procedures in an Organization
24
• The 4 Ps of Safety Management– Management Philosophy– Specifying how safety will be achieved
through People– What management wants people to do
(Procedures) to execute the policy– Practice - What really happens on the job
Adapted from: TP 13739 E Introduction to Safety Management Systems, Transport Canada