Planetary Gearbox - ROMETEC · 3 Double-lipped radial shaft seals made of VITON allow continuous operation and have a very good chemical resistance. High linear stiffness charac-teristic,

Planetary GearboxStöber Series P

Rometec srl - www.rometec.it - Rometec srl - www.rometec.it - Rometec srl - www.rometec.it


2



3

Double-lipped radial shaft

seals made of VITON allow

continuous operation and

have a very good chemical resistance.

High linear stiffness charac-

teristic, minimal torsional backlash and an extremely

low level of operational noise

are all achieved by optimised

helical gears.

Single piece ductile iron

housing with two bearings,

provides greater concen-tricity and more precise

alignment.

Ring gear directly machined

in the housing which is cast

from high tensile ductile iron.

The motor mounting system

with flange and adapter

bushing allows installation of

motor in minutes - no special

tools required.

Oversized bearings ensure a high load factor together

with axial and radial rigidity

of the output shaft.

Input shaft bearing with

seals and high temperature

grease.

Single part planet carrier

made of high-rigidity ma-

terial with a minimum ten-sile strength of 500N/mm².

Highest torsional rigidtity

due to generous dimensions.

Each piece is balanced toprovide smooth and uniform

running.

Adapter bushings fit all

motor shafts - no key re-quired.

Sun gears and planetary

gears case-hardened to

61 HRC and ground. Highquality gearing.

Balanced, low inertia alu-

minium clamp ring to mini-mise high speed vibration.

The planetary gears have bearings on both sides. This

minimises the deflection re-

sulting from axial and radial

forces.

Triple-split steel collet for

precise clamping of themotor shaft.

Lubricated for life with

high quality synthetic gear

oil.

Aluminium casing and motormounting flange reduce the

weight of the gearbox.

Motor mounting flange

compatible with Parker servo motors.

Seals on smallest possible

shaft diameter reduce fric-

tion and therefore the heat,

which in turn increases theefficiency. Continuous

operation without additional

cooling is possible. Protec-

tion class IP65.



4



5

rperm.



6



7



8



9



10



11



We reserve the right to make technical changes. The data correspond to the technical state at the time of printing. 192-753011N6 April 2008

© 2008 Parker Hannifin Corporation

Parker Hannifin GmbH & Co. KG

Electromechanical Automation

Robert-Bosch-Straße 22

D-77656 Offenburg, Germany

phone +49 (0)781 / 509-0

fax +49 (0)781 / 509-98176

[email protected]

www.parker-automation.com



Documents

Planetary Gearbox - ROMETEC · 3 Double-lipped radial shaft seals made of VITON allow continuous operation and have a very good chemical resistance. High linear stiffness charac-teristic,