Upload
richard-coffey
View
191
Download
1
Embed Size (px)
Citation preview
Container Ships Cruise Liners Aircraft Carriers Oil Tankers Private Yachts Oil Rigs Below Sea Piping
Marine Pipeline Support Services Pipe rehabilitation by non-destructive techniques.
Container Ships Cruise Liners Aircraft Carriers Oil Tankers Private Yachts Oil Rigs Below Sea Piping
Nu Flow is a member of the Aquam group, offering 300 years of accumulated experience in
the water and gas pipeline industry.
Specialists in small diameter pipe rehabilitation and offer bespoke services for large diameter
pipelines.
With reactive and proactive solutions, our product’s estimated 100 year lifespan offers a
permanent solution to prevent corrosive sea water from damaging pipelines and systems.
Hot and Cold Potable Water Systems
Lead Pipes
Compressed Air
HVAC / Hydronic and Chiller Systems
Fire Suppression Systems
Processed Conduit & Chemical Piping
Gas Lines
Epoxy Coating Structural Liner
Common Applications
Vertical Sanitary Stacks
Horizontal Sewer Branches
Sewer Mains
Roof Drain Systems
Spot Repair Liners
Non-disruptive
Significant reduction in commercial costs
Minimal downtime
Fixes leakages
Increases pressure and flow
Prevents future corrosion
Removes contaminants
Reduces the risk of legionella
Benefits of Using Our Technology
Case Study: US Navy Aircraft Carriers
Copper-nickel CHT systems located throughout the carriers (used
as waste drain systems), ranging from 100mm (4”) to 150mm (6”)
diameters.
Systems only had 18 month lifespan once in service and became
severely corroded due to waste and seawater travelling through the
pipes.
Corrosion caused deterioration and leaks throughout the vessels.
Nu Flow successfully cleaned and coated the systems to offer a
permanent solution.
Costs were one-tenth of the cost to pipe replacement solutions.
US Navy have strong faith in the product –Nu Flow have
rehabilitated almost 40 vessels as a result.
Built in 1964, rehabilitated in 1994.
Severely corroded fuel distribution pipes.
Pipe replacement would have cost millions of
dollars and caused damage to the ship.
Nu Flow successfully cleaned and lined 460mm (18”),
500mm (20”) and 560mm (22”) fuel distribution
pipes.
No destruction was caused to the ship.
Epoxy resin will prevent future corrosion.
Case Study: SS Chesapeake Oil Tanker
The sounding pipe used in manual water
measurement was badly corroded at one access
point.
Nu Flow successfully cleaned and lined the pipe.
No disruption or displacement was caused during
rehabilitation.
Future corrosion was prevented as a result of
our unique, strong epoxy resin.
Case Study: GSF Grand Banks Oil Rig
Fire suppression water system at the centre which trains more than 35,000 military
personnel each year.
Six buildings housing a state of the art computerized fire simulator built for the U.S.
Navy in 1993.
Over half a mile of black steel pipe ranging from 40mm (1 ½”) to 150mm (6”) in
diameter with multiple elbows, tees and transitions in diameter size.
Several buildings at the facility were experiencing multiple plumbing leaks. Re-piping
was considered but rejected due to high costs and lengthy down time.
Nu Flow used compressed air and garnet to clean the inside of the entire piping system
and then applied an evenly-coated layer of their patented epoxy to stop leaks and
prevent future corrosion.
Nu Flow successfully upgraded the durability of the fire suppression system and
coordinated the project by stages. They formulated a work schedule that promoted
clear lines of communication with the naval base personnel regarding the ongoing
work.
Case Study: Naval Base Training Centre
Waterfront Hotel sitting at sea level.
The sanitary drain line ran below the oceans water
table.
Corrosive sea water ate away at the drain line.
System was 70 feet of 4” cast iron pipe.
Nu Flow’s ‘Nu Drain’ was used to rehabilitate the
line and protect it from the ocean water.
No unsightly construction, and no disruption or
inconvenience was caused.
Case Study: Below Sea Level Pipes
Any Questions?
Please contact;
Dermott Finn
m: 077702 40849
Further case studies can be located at :
http://www.nuflowtech.com/case-studies/
For more information please visit our website;
www.nufloweurope.co
Or contact;
Ireland: +353 (0)1 6510302
Unit H2, Maynooth Business Campus, Straffan Road, Maynooth, Co. Kildare, Ireland, W23 KH76.
UK: +44 844 543 3540
Kingsley Hall, 20 Bailey Lane, Manchester Airport, Manchester, UK, M90 4AN.
.
.