Invacare® I-Lift® · Electric Lift - Mast / Boom Assembly NOTE: Items that are not shown in this category but are included in Kits in the Parts List are used on other I-Lift Applications

Invacare® I-Lift®Patient Transport Lift

Parts Catalog Issued: Jan 29, 2019

The information contained in this document is subject to change without notice. This catalog containsservice parts for Form No. 12-678. If you have any questions regarding this catalog, please contact oneof our Customer Service Representatives.

For Customer Service Support Call:1-800-333-6900

For Faxed In Orders Call:1-800-678-4682 or

1-440-366-0709For Technical Service Call:

1-800-832-4707Literature Can Be Found at:

www.invacare.com or1-800-828-6272

SYMBOL DEFINITIONThroughout this catalog you will notice letters to draw your attention to specific footnotes which are located at thebottom of the page or below specified charts.

HARDWARE MEASUREMENTS

Examples:= Special Comments= General information pertaining to that specific page= No Longer Available

NOTE:NLA

The measurements for the hardware will be listed as follows:Screws, BoltsWashersSpacers

For your convenience, we have supplied an area for you to list your Invacare Representatives.

A,B,C etc.

Diameter X Thread Count/Pitch X LengthInside Diameter X Outside Diameter X ThicknessInside Diameter X Outside Diameter X Length

Name Phone Numbers

© 2019 Invacare Corporation. All rights reserved. Republication, duplication or modification in whole or in part is prohibited without prior written permissionfrom Invacare. Trademarks are identified by ™ and ®. All trademarks are owned by or licensed to Invacare Corporation or its subsidiaries unless otherwise

noted.

Parts Catalog Usage Guide

1Form No. 12-678 To order call toll free 1-800-333-6900, or www.invacare.com

00. Product Pictures ................................................................................................................. 3

01. ILIFTEE - Electric Lift - Mast / Boom Assembly ................................................................. 4

02. ILIFTEE - Electric Lift - Hanger Bar, Labels, Battery Pack and Controller ......................... 7

03. ILIFTEE - Electric Lift - Base .............................................................................................. 10

04. ILIFTHM - Hydraulic Lift - Mast / Boom Assembly ............................................................. 12

05. ILIFTHM - Hydraulic Lift - Hanger Bar and Labels ............................................................. 15

06. ILIFTHM - Hydraulic Lift - Base .......................................................................................... 17

07. ILIFTEM - Manual Lift - Mast / Boom Assembly ................................................................. 20

08. ILIFTEM - Manual Lift - Hanger Bar, Labels, Battery Pack and Controller ......................... 23

09. ILIFTEM - Manual Lift - Base ............................................................................................. 27

TABLE of CONTENTSDescription Page

Number

2To order call toll free 1-800-333-6900, or www.invacare.comForm No. 12-678

Product Pictures


Electric Lift - Mast / Boom AssemblyNOTE: Items that are not shown in this category but are included

in Kits in the Parts List are used on other I-Lift Applications. All fasteners must be torqued to IFI/DINstandards.




ItemNumber Part Number DescriptionNote

Quantity PerPackage Assembly

1156153 Boom Assembly 1 111156148 Mast Assembly, Electric 1 121156267 Push Handle 1 231078273 Actuator Motor 1 141177610 NLA - Kit, Boom Mounting Hardware 1 15 A

Cap, End 1 411Screw, Hex Head (M10 x 1.5 x 58mm) 1 112Screw, Shoulder Hex Socket Head (3/8 x 1-1/2",5/16-18)

1 113Washer (10.5 x 20 x 2mm) 1 414Locknut (M10 x 1.5mm) 1 215Bushing (10 x 18 x 49mm) 1 116Bearing, Teflon 1 217Screw, Hex Head (M10 x 1.5 x 80mm) 1 118Washer, Nylon (20 x 10.2 x 4.2mm) 1 219Locknut (5/16-18) 1 120Bushing (10 x 12 x 28mm) 1 125

1177611 Kit, Push Handle Mounting Hardware 1 16 BCap, End 1 411Washer (10.5 x 20 x 2mm) 1 414Locknut (M10 x 1.5mm) 1 215Screw, Hex Head (M10 x 1.5 x 75mm) 1 229

1177612 NLA - Kit, Actuator Hardware, Mast 1 17 CProtector, Mast 1 121Screw, Socket Head Cap (M5 x .8 x 10mm) 1 222Clip, Hydraulic 1 141Clip, Actuator 1 123Rivet (4 x 14mm) 1 224Screw, Socket Button Head (M5 x .8 x 12mm) 1 226

1177613 Kit, Actuator Mounting Hardware 1 18 DCap, End 1 211Screw, Hex Head (M10 x 1.5 x 58mm) 1 112Washer (10.5 x 20 x 2mm) 1 214Locknut (M10 x 1.5mm) 1 115Bushing (10 x 12 x 28mm) 1 125Lock, Wire 1 127

1177615 Kit, Folding Hook 1 19 EHook, Folder 1 130Pin, Locking shaft (10 x 50mm) 1 131Pin (8 x 36mm) 1 132Spring, Hook 1 133

1177614 Kit, Mast Connector Hardware 1 110 F5

To order call toll free 1-800-333-6900, or www.invacare.comForm No. 12-678





Washer (10.5 x 20 x 2mm) 1 414Locknut (M10 x 1.5mm) 1 215Bearing (16 x 10 x 25mm) 1 228Screw, Hex Head (M10 x 1.5 x 75mm) 1 229Washer (5.2 x 10 x 1mm) 1 134Pin, Lock Plate (M5 x 80mm) 1 135Spring (.5 x 5 x 50mm) 1 136Plate, Lock 1 137Ball (20mm) w/ Stud, Threaded (M6 x 1 x 13mm) 1 138Rubber, Anti Scratch 1 139Screw (M4 x 7mm) 1 140

A - Includes items 11 - 20, and 25. Items 13, 19, and 20 are not used on this Model and are not shown. B - Includes items 11, 14 - 15, and 29. C - Includes items 21 - 24, 26, and 41. Item 41 is not used on this Model and is not shown. D - Includes items 11 - 12, 14, 15, 25, and 27. E - Includes items 30 - 33. F - Includes items 14, 15, 28, 29, and 34 - 40.

NOTE: Some Items that are not shown on Illustration but are included in Kits on this page are used for other I-Lift Applications. All fasteners must be torqued to IFI/DIN standards.

NOTE:


Electric Lift - Hanger Bar, Labels, Battery Pack andController

NOTE: All fasteners must be torqued to IFI/DIN standards.

NOTE: Item #22 Battery and Bracket Kit is currently not available at this time. Use Items 23, 24, and 25 toreplace battery.











1177616 Kit, Hanger Bar Mounting Hardware 1 11 APlug, Boom 1 15Foam, Cover 1 16Pin, Clevis (M10) 1 17Clip (M10) 1 18

1177617 Kit, Hanger Bar Retainer Strap and Plug Button 1 12 BPin, Roll 1 610Strap Retainer 1 611Plug, Hanger Bar 1 412

1177618 Kit, Hanger Bar Pin Assembly 1 13 CClip, "C" 1 113O-Ring 1 214Washer, Bearing 1 115Pin, Hanger Bar 1 116

1177620 Kit, Label 1 14 DLabel, Weight US 1 117Label, I-Lift 1 218Decal, Invacare Logo (3.1) 1 219Label, Sling 1 220Label, Warning, Lift, 450 Pound Capacity 1 121

1177621-NLA NLA - Kit, Battery and Mounting Bracket 1 122 EBracket, Battery - Electric Only 1 123Screw, Phillips, Pan Head (10-24 x 1/4") 1 324Battery 1 125

1078284 Bracket, Battery - Electric Only 1 1231078980 Screw, Phillips Pan Head (#10-24 x 1/4") 1 3241152383 Battery Pack 1 1251177640 Hanger Bar Assembly 1 191175309 Controller 1 1261177596 Pendant, Four Channel w/ Hook 1 1271078306 Bracket, Wall Mount Charger - Electric Only 1 1281175312 Charger 1 1291079133 Cord, USA - Electric Only 1 130

A - Includes items 5, 6, 7, and 8. B - Includes items 10, 11, and 12. C - Includes items 13, 14, 15, and 16. D - Includes items 17, 18, 19, 20, and 21. E - 1177621 is not currently available at this time, please use the following part numbers as replacements, item 23 (1078284),

item 24 (1078980), and item 25 (1152383).

NOTE:

9


Electric Lift - Base



Electric Lift - Base

NOTE: All fasteners must be torqued to IFI/DIN standards.Item

Number Part Number DescriptionNoteQuantity Per

Package Assembly1156139 Leg Assembly 1 211175245 Cover, Leg Protection 1 221156232 Shroud, Electric Base 1 131023632 Clip, Shroud 1 341175313 Actuator 1 1301177622 Kit, Rear Caster w/ Hardware, Locking (Pair) 1 15 A

Screw, Socket, Countersunk Head (M10 x 1.5 x85mm)

1 210Spacer (41.3 x 10.2 x 15mm) 1 211Caster, Rear Locking 1 212Locknut (M10 x 1.5mm) 1 221

1177623 Kit, Front Caster w /Hardware (Pair) 1 16 BScrew, Socket, Countersunk Head (M10 x 1.5 x70mm)

1 213Spacer (40 x 10.5 x 3mm) 1 214Caster, Front 1 215Locknut (M10 x 1.5mm) 1 221

1177624-NLA NLA - Kit, Leg to Crossmember Mounting Hardware(Pair)

1 17 CBushing, Bronze 1 416Bushing, Base and Leg 1 217Screw, Socket Button Head, (M10 x 1.5 x 22mm) 1 218Lock Washer, Split (M10) 1 231

1177625 Kit, Actuator Mounting Hardware 1 18 DWasher (10.5 x 20 x 2mm) 1 219Plate, Support, Electric Base 1 120Locknut (M10 x 1.5mm) 1 221Washer (28mm x 12mm x 2mm) 1 122Pin, Hitch (3/8 x 1-3/16") 1 123Bearing, Flange (12mm x 18mm x 7.6mm) 1 124Screw, Socket Head (M12 x 1.75 x 30mm) 1 125NLA - Pin, Clevis (10mm x 44mm) 1 126Bracket, Linkage 1 127

1177629 Kit, Linkage (Pair) 1 19 EScrew, Socket Button Head w/ Patch (M8 x 1.25 x25mm)

1 428Tie Rod Assembly 1 229

A - Includes items 10-12 and 21. B - Includes items 13-15 and 21. C - Includes items 16-19. D - Includes items 19-27. E - Includes items 28-29.

NOTE:

11


Hydraulic Lift - Mast / Boom AssemblyNOTE: Items that are not shown in this category but are included







1156153 Boom Assembly 1 111156241-NLA NLA - Mast Assembly, Hydraulic 1 12

1156267 Push Handle 1 231175231-NLA NLA - Pump, Hydraulic 1 14

1177610 NLA - Kit, Boom Mounting Hardware 1 15 A,C,D,E



1177611 Kit, Push Handle Mounting Hardware 1 16 FCap, End 1 410Washer (10.5 x 20 x 2mm) 1 413Locknut (M10 x 1.5mm) 1 214Screw, Hex Head (M10 x 1.5 x 75mm) 1 228

1177612 NLA - Kit, Actuator Hardware, Mast 1 17 BProtector, Mast 1 120Screw, Socket Head Cap (M5 x .8 x 10mm) 1 221Clip, Hydraulic 1 122Clip, Actuator 1 125Rivet (4 x 14mm) 1 224Screw, Socket Button Head (M5 x .8 x 12mm) 1 226

1177614 Kit, Mast Connector Hardware 1 18 GWasher (10.5 x 20 x 2mm) 1 413Locknut (M10 x 1.5mm) 1 214Bearing (16 x 10 x 25mm) 1 227Screw, Hex Head (M10 x 1.5 x 75mm) 1 228Washer (5.2 x 10 x 1mm) 1 133Pin, Lock Plate (M5 x 80mm) 1 134Spring (.5 x 5 x 50mm) 1 135Plate, Lock 1 136Ball (20mm) w/ Stud, Threaded (M6 x 1 x 13mm) 1 137Rubber, Anti Scratch 1 138Screw (M4 x 7mm) 1 139






1177615 Kit, Folding Hook 1 19 HHook, Folder 1 129Pin, Locking shaft (10 x 50mm) 1 130Pin (8 x 36mm) 1 131Spring, Hook 1 132

A - Includes items 10 - 19 and 23. Items 12 and 23 are not used on this Application and are not shown in the illustration. B - Includes items 20 - 22 and 24 - 26. Item 25 is not used on this Application and is not shown in the illustration. C - Hydraulic Lift requires only (2) of Item 10. D - Hydraulic Lift requires only (2) of Item 14. E - Hydraulic Lift requires only (2) of Item 17. F - Includes items 10, 13, 14, and 28. G - Includes items 13, 14, 27, 28, and 33 - 39. H - Includes items 29 - 32.

NOTE: Items that are not shown in this category but are included in Kits in the Parts List are used on other I-Lift Applications.

NOTE:


Hydraulic Lift - Hanger Bar and Labels



Hydraulic Lift - Hanger Bar and Labels



Package Assembly1177616 Kit, Hanger Bar Mounting Hardware 1 11 A

Plug, Boom 1 15Foam, Cover 1 16Pin, Clevis (M10) 1 17Clip (M10) 1 18

1177640 Hanger Bar Assembly 1 19 B1177617 Kit, Hanger Bar Retainer Strap and Plug Button 1 12 C

Pin, Roll 1 610Strap Retainer 1 611Plug, Hanger Bar 1 412

1177618 Kit, Hanger Bar Pin Assembly 1 13 DClip, "C" 1 113O-Ring 1 214Washer, Bearing 1 115Pin, Hanger Bar 1 116

1177620 Kit, Label 1 14 ELabel, Weight US 1 117Label, I-Lift 1 218Decal, Invacare Logo (3.1) 1 219Label, Sling 1 220Label, Warning, Lift, 450 Pound Capacity 1 121

A - Includes items 5, 6, 7, and 8. B - Includes the Hanger Bar and items 10, 11, and 12. C - Includes items 11, 12, and 13. D - Includes items 13, 14, 15, and 16. E - Includes items 17 - 21.

NOTE:


Hydraulic Lift - Base






Package Assembly1156139 Leg Assembly 1 211175245 Cover, Leg Protection 1 221156233 Shroud, Manual Base 1 131023632 Clip, Shroud 1 341177622 Kit, Rear Caster w/ Hardware, Locking (Pair) 1 15 A







1177626-NLA NLA - Kit, Index Plate w /Hardware 1 18 DWasher (10.5 x 20 x 2mm) 1 221Index Plate Assembly 1 122Locknut (M10 x 1.5mm) 1 223

1177627 Kit, Handle Mount 1 19 EHandle, Mount 1 124Spring, Compression (1 x 1-1/16 x 1/8") 1 125Screw, Shoulder Hex Socket Head w/ Patch (1/2" x1-1/4", 3/8-16)

1 1261177629 Kit, Linkage (Pair) 1 110 F

Screw, Socket Button Head w/ Patch (M8 x 1.25 x25mm)


1177628 NLA - Kit, Handle w /Grip 1 111 GHandle 1 129Grip, Cane 1 130



NOTE: All fasteners must be torqued to IFI/DIN standards.A - Includes items 12-14 and 23. B - Includes items 15-17 and 23. C - Includes items 18-21. D - Includes items 21-23. E - Includes items 24-26. F - Includes items 27-28. G - Includes items 29-30.

NOTE:


Manual Lift - Mast / Boom Assembly






Package Assembly1156153 Boom Assembly 1 111156240 Mast Assembly, Manual 1 121156267 Push Handle 1 231078273 Actuator Motor 1 141177610 NLA - Kit, Boom Mounting Hardware 1 15 A



1177611 Kit, Push Handle Mounting Hardware 1 16 BCap, End 1 411Washer (10.5 x 20 x 2mm) 1 414Locknut (M10 x 1.5mm) 1 215Screw, Hex Head (M10 x 1.5 x 75mm) 1 229

1177612 NLA - Kit, Actuator Hardware, Mast 1 17 CProtector, Mast 1 121Screw, Socket Head Cap (M5 x .8 x 10mm) 1 222Clip, Hydraulic 1 141Clip, Actuator 1 123Rivet (4 x 14mm) 1 224Screw, Socket Button Head (M5 x .8 x 12mm) 1 226

1177613 Kit, Actuator Mounting Hardware 1 18 DCap, End 1 211Screw, Hex Head (M10 x 1.5 x 58mm) 1 112Washer (10.5 x 20 x 2mm) 1 214Locknut (M10 x 1.5mm) 1 115Bushing (10 x 12 x 28mm) 1 125Lock, Wire 1 127

1177615 Kit, Folding Hook 1 19 EHook, Folder 1 130Pin, Locking shaft (10 x 50mm) 1 131Pin (8 x 36mm) 1 132Spring, Hook 1 133





Package Assembly1177614 Kit, Mast Connector Hardware 1 110 F

Washer (10.5 x 20 x 2mm) 1 414Locknut (M10 x 1.5mm) 1 215Bearing (16 x 10 x 25mm) 1 228Screw, Hex Head (M10 x 1.5 x 75mm) 1 229Washer (5.2 x 10 x 1mm) 1 134Pin, Lock Plate (M5 x 80mm) 1 135Spring (.5 x 5 x 50mm) 1 136Plate, Lock 1 137Ball (20mm) w/ Stud, Threaded (M6 x 1 x 13mm) 1 138Rubber, Anti Scratch 1 139Screw (M4 x 7mm) 1 140

A - Includes items 11-20 and 25. Items 13, 19 and 20 are not used on this Model and are not shown. B - Includes items 11-15 and 29.. C - Includes items 21-24, 26 and 41. Item 41 is not used on this Model and is not shown. D - Includes items 11-12, 14-15, 25 and 27. Item 27 is not used on this Model and is not shown. E - Includes items 30-33. F - Includes items 14-15, 28-29 and 34-40.

Note: Items that are not shown on Illustration but are included in Kits on this page are used for other Model Applications.

NOTE:


Manual Lift - Hanger Bar, Labels, Battery Pack andController













1177616 Kit, Hanger Bar Mounting Hardware 1 11 APlug, Boom 1 15Foam, Cover 1 16Pin, Clevis (M10) 1 17Clip (M10) 1 18

1177617 Kit, Hanger Bar Retainer Strap and Plug Button 1 12 BPin, Roll 1 610Strap Retainer 1 611Plug, Hanger Bar 1 412

1177618 Kit, Hanger Bar Pin Assembly 1 13 CClip, "C" 1 113O-Ring 1 214Washer, Bearing 1 115Pin, Hanger Bar 1 116

1177620 Kit, Label 1 14 DLabel, Weight US 1 117Label, I-Lift 1 218Decal, Invacare Logo (3.1) 1 219Label, Sling 1 220Label, Warning, Lift, 450 Pound Capacity 1 121

1177640 Hanger Bar Assembly 1 19 E1177621-NLA NLA - Kit, Battery and Mounting Bracket 1 122 F,G

Bracket, Battery - Electric Only 1 123Screw, Phillips, Pan Head (10-24 x 1/4") 1 324Battery 1 125

1078284 Bracket, Battery - Electric Only 1 1231078980 Screw, Phillips Pan Head (#10-24 x 1/4") 1 3241152383 Battery Pack 1 1251175310 Controller 1 1261177595 Pendant, Two Channel w/ Hook 1 1271078306 Bracket, Wall Mount Charger - Electric Only 1 1281175312 Charger 1 1291079133 Cord, USA - Electric Only 1 130





A - Includes items 5, 6, 7, and 8. B - Includes items 10, 11, and 12. C - Includes items 13, 14, 15, and 16. D - Includes items 17 - 21. E - Includes Hanger Bar and items 11, 12, and 13. F - Includes items 23, 24, and 25. G - 1177621 is not currently available at this time, please use the following part numbers as replacements, item 23 (1078284),

item 24 (1078980), and item 25 (1152383).

NOTE:


Manual Lift - Base



Manual Lift - Base



Package Assembly1156139 Leg Assembly 1 211175245 Cover, Leg Protection 1 221156233 Shroud, Manual Base 1 131023632 Clip, Shroud 1 341177622 Kit, Rear Caster w/ Hardware, Locking (Pair) 1 15 A







1177626-NLA NLA - Kit, Index Plate w /Hardware 1 18 DWasher (10.5 x 20 x 2mm) 1 221Index Plate Assembly 1 122Locknut (M10 x 1.5mm) 1 223

1177627 Kit, Handle Mount 1 19 EHandle, Mount 1 124Spring, Compression (1 x 1-1/16 x 1/8") 1 125Screw, Shoulder Hex Socket Head w/ Patch (1/2" x1-1/4", 3/8-16)

1 1261177629 Kit, Linkage (Pair) 1 110 F

Screw, Socket Button Head w/ Patch (M8 x 1.25 x25mm)


1177628 NLA - Kit, Handle w /Grip 1 111 GHandle 1 129Grip, Cane 1 130


Manual Lift - Base

NOTE: All fasteners must be torqued to IFI/DIN standards.A - Includes items 12-14 and 23. B - Includes items 15-17 and 23. C - Includes items 18-21. D - Includes items 21-23. E - Includes items 24-26. F - Includes items 27-28. G - Includes items 29-30.

NOTE:


Invacare Corporation www.invacare.com

One Invacare WayElyria, Oh USA44036-2125800-333-6900

Technical Support800-832-4707Customer Service800-333-6900

Literature Orders800-333-6900

Form No. 12-678

© 2019 Invacare Corporation. All rightsreserved. Republication, duplication ormodification in whole or in part is prohibitedwithout prior written permission fromInvacare. Trademarks are identified by ™and ®. All trademarks are owned by orlicensed to Invacare Corporation or itssubsidiaries unless otherwise noted.(Revised 01/29/19)

Documents

Invacare® I-Lift® · Electric Lift - Mast / Boom Assembly NOTE: Items that are not shown in this category but are included in Kits in the Parts List are used on other I-Lift Applications