IMPORTANT INSTRUCTIONS·OPERATING MANUAL'

-PERFORMANCEAIR CLEANE~

MODEL 1EFV7/9900 '.

This Air Cleaner is not intended to be used in commercial, industrial or agricultural settings .

•READ AND SAVE THESE INSTRUCTIONSREAD CAREFULLY BEFORE ATTEMPTING TO ASSEMBLE,

. INSTALL, OPERATE OR MAINTAIN THE PRODUCT DESCRIBED.PROTECT YOURS~LF AND OTHERS BY OBSERVING ALL

SAFETY INFORMATION. FAILURE TO COMPLY WITHINSTRUCTIONS COULD RESULT IN PERSONAL INJURY ANDIOR

PROPERTY DAMAGE!KEEP INSTRUCTIONS FOR FUTURE REFERENCE ..

New 6/07 2085456 .

S.AVETHESE INSTRUCTIONS

I IGENERAL SAFETY INFORMATION

When using electrical appliances, basic precautions should always be followed toreduce the risk of fire, electrical shock and injury to persons, including the following:

@ Read all instructions before using this Air Cleaner. @1. Make certain the power source conforms to the electrical requirements of the Air Cleaner.2. Make certain that the room is equipped with a working smoke detector.3. Use this Air Cleaner only as described in this manual. Any other use not recommended by the manufacturer may cause fire, electrical

shock, or injury to persons.4. To reduce the risk of personal injury and electric shock, the Air Cleaner should not be played with or placed where small children can reach it.5. Unplug power cord before installing, servicing, or moving the Air Cleaner.

&1 itWARNING 1&

'--

DO NOT DEPEND ON THE ON/OFF SWITCH AS THE SOLE MEANS OF DISCONNECTING POWER WHEN SERVICINGOR MOVING THE AIR CLEANER. ALWAYS UNPLUG THE POWER CORD. ALWAYS TURN OFF AND UNPLUG AIRCLEANER BEFORE LEAVING THE AREA. NEVER LEAVE CHILDREN UNATTENDED WHEN THE AIR CLEANERIS ON OR PLUGGED IN.6. This Air Cleaner must NOT be used in potentially dangerous locations such as flammable, explosive, chemical-laden or wet atmospheres

where gaSOline, paint or flammable liquids are used or stored.7. DO NOT use Air Cleaner in or near a window. Rain may create an electrical hazard.

~WARNING 1This plug is a safety feature, to reduce the risk of fire, electric shock and personal injury. DO NOT remove, replace, repair or-tamperwith the originally supplied plug. If the Fan does not function properly, it may be due to the safety device incorporated in this plug.Contact your Grainger Distributor.8. The power cord is equipped with a three-prong grounded plug that must be inserted into a matching receptacle. Under no circum-

stances must the grounding prong be cut off the plug. Where a two-prong wall receptacle is encountered, it must be replaced with aproperly grounded three-prong receptacle installed in accordance with the National Electrical Code (NEC) and all applicable focal codesand ordinances. This work must be done only by a qualified electrician, using copper wire only.

9. Where possible, avoid the use of extension cords because the extension cord may overheat and cause a fire. If you must use an extensioncord, minimize the risk of overheating by using the shortest cord possible and ensuring that it is UL listed. NEVER use a single extensioncord to operate more than one Air Cleaner. DO NOT plug Air Cleaner into any powerstrip, cord reel, surge protector, multiple outletadapters or outlet-type air fresheners. The use of such devices may create a tire hazard.

10. NEVER operate any Air Cleaner with a damaged cord or plug or after the Air Cleaner malfunctions, has been dropped or damaged in anymanner. There are no user serviceable parts. Return Air Cleaner to an authorized service facility for examination, electrical or mechanicaladjustment or repair.

11. :NEVER insert or allow fingers or foreign objects to enter any ventilation or exhaust opening as it may cause an electric shock or fire, or'darnaqe the Air Cleaner. To reduce the risk of fire, DO NOT block or tamper with the Air Cleaner in any manner while it is in operation.

12. !Always place the Air Cleaner on a stable, flat, level surface when operating, to avoid the chance of the Air Cleaner overturning. Locate theIPower Cord so the Air Cleaner or other objects are not resting on it. DO NOT run Power Cord under carpeting. DO NOT cover Power Cord! with. throw rugs, runners or the like. Arrange Power Cord away from room traffic and where it will not be tripped over.

13. This Air Cleaner is not intended for use in wet or damp locations. NEVER locate a Air Cleaner where it may fall into a bathtub or otherwater container. NEVER use Air Cleaner where flammable liquids are used or stored.

14. NEVER use Air cleaner outdoors.15. Warning: Not intended for industrial ventilation of V.D.C.s - as used in painting, paint fumes, mist, etc.16. This Air Cleaner is not suitable Jor use in agricultural facilities including areas where livestock, poultry or other animals are confined. Please

refer to National Electric Code (NEG) Article 547-7 (2002), or applicable state or local codes or standards relating to electrical requirementsfor Agricultural Buildings. THIS AIR CLEANER DOES NOT MEET THE REQUIRMENTS OF NEC ARTICLE 547-7 (2002).

17. This Air Cleaner is not suitable for use in hazardous locations. Please refer to National Electric Code (NEG) Article 500 or applicable stateor local codes or standards relating to electrical requirements for Hazardous locations. THIS AIR CLEANER DOES NOT MEET THEREQUIRMENTS OF NEC ARTICLES 500 (2002)

,04

REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK - DO NOT USE THIS AIR CLEANER WITH ANY SOLIDSTATE SPEED CONTROL DEVICES.

SAVE THESE INSTRUCTIONSNew 6/07 2 2085456

MODEL 1EFV7/9900DESCRIPTIONAir King Performance Air Cleaner features 3 quiet speeds and manualcontrols. Filtration feature brings dean air into the area. The Air Cleanerhas a permanently lubricated motor and comes with a 6 ft (1.8m) 18/3cord set.

SPECIFICATIONSMotor 120V, 60HzBlade Diameter 20"Speeds 3Control. ManualApprovals UL Listed. Close mesh fan guard meets OSHArequirements.

MODEL 1EFY7/9900ISPEED HIGH MED LDWCFM* 1075 900 690RPM 840 700 540Amps 1.0 0.77 0.60Watts 113 93 72dBA 40 36 32

* Performance based on uSing 68938 fllt~r

ASSEMBLY1. Remove the feet from the cardboard holder on top of the air cleaner.2. Remove the air cleaner and filter assembly from carton.3. Remove adhesive tape from the bottom of the filter holder.4. Place Air Cleaner with front side facing down. Attach feet to the

BACK OF AIR CLEANER in the following manner:a) Push hook on the front of the FOOT into the BOTTOM

$LOT on the underside of the unit. (FIGURE 1A)b) Pivot up. (FIGURE 1B)c) Snap into place. (FIGURE 1B)

5. Install FILTER into the FILTER HOLDER. (FIGURE 2) Be sure thearrow, printed on the side of the filter, is facing the air cleaner, toensure the maximum benefits of the air cleaner. Turn the CLIPS,(see INSERT 2A)on the left and right side of the filter holder, tosecure the filterInto place.

6. Place the BOnOM OFTHE FILTER HOLDER into the recessedarea of the foot.

7. Push the filter holder towards the air cleaner. (FIGURE 3A)8. When the filter meets the back of the air cleaner, lock the tabs

down, on the top rear of the filter holder. (FIGURE 3B)

FOOT

/

PBACK OF AIR CLEANER

-+---- BOTTOMSLOT

FIGURE 1A

New 6/07

FILTER PERFORMANCE/SELECTIONThe Air Cleaner will remove debris and particles based on the typeand rating of the filter used. This unit comes equipped with GraingerItem# 6B938. Please refer to the enclosed Filter Selction InformationChart on page 4 for further information regarding CFM output of otherfilter selections available from Grainger.

PATj:NTS PENDING

OPERATION1. Be sure the Air Cleaner Control Knob

is in the "OFF" (0) position. .2. PIug the Air Cleaner into any standard

120V AC household outlet.3. Place the Air Cleaner in a place

where the performance will not beobstructed.

4. This Air Cleaner is effective whether itis facing towards or away from you.

5. Turn the Air Cleaner "ON" by using thecontrol knob on top of the unit. Adjustto desired speed: High (3), Medium(2), OR Low (1). (FIGURE 4)

6. This Air Cleaner can be used as aFan without the filter. FIGURE 4

BACK OF AIR CLEANER

FIGURE 1B

FILTERHOLDER

'INSERT2A

3

FIGURE3B

2085456

-,\ .

MODEL 1EFV7/9900TROUBLESHOOTING GUIDE

PROBLEM PROBABLE CAUSE SUGGESTED REMEDY1. Change filter.2. Make sure snaps are locked into place.3. Make sure there are no obstructions around

the grill .

Air Cleaner is not filtering air. 1. Filter is clogged.2. Filter holder is not securely in place.3. No air movement.

• Fuse or circuit breaker is main and branch

. Filter Selection Information ChartTo select the appropriate filter for your application see your Grainger catalog or contact your local branch for details.

CFM Filter Description High Med Low6B938 High Capacity Pleated Media 1075 900 690

Filter Item 1W097 Fiberglass Media 1400 1160 825Numbers 5W511 Standard Capacity Pleated Media 1054 905 640

6B886 Carbon Impregnated Pleated Media 1090 885 6655W896 Electostatic Media 1025 825 690

LIMITED WARRANTYWHAT THIS WARRANTY COVERS: This product is warranted against defects in workmanship and/or materials.HOW LONG THIS WARRANTY LASTS: This warranty extends only to the original purchaser of the product and lasts for one (1) year from the date of originalpurchase or until the original purchaser of the product sells or transfers the product, whichever first occurs.WHAT AIR KING WILL DO: During the warranty period, Air King will, at its sole option, repair or replace any part or parts that prove to be defective or replacethe whole product with the same or comparable model.WHAT THIS WARRANTY DOES NOT COVER: This warranty does not apply if the product was damaged or failed because of accident, improper handling oroperation, shipping damage, abuse, misuse, unauthorized repairs made or attempted, or the use of the product for commercial or nonresidential service. Thiswarranty does not cover shipping costs for the return of products to Air King for repair or replacement. Air King will pay return shipping charges from Air Kingfollowing warranty repairs or replacement

ANY AND ALL WARRANTIES, EXPRESSED OR IMPLIED (INCLUDING, WITHOUT LIMITATION, ANY IMPLIED WARR.ANTY OF MERCHANTABILITY),LAST ONE YEAR FROM THE DATE OF ORIGINAL PURCHASE OR UNTIL THE ORIGINAL PURCHASER OF THE PRODUCT SELLS OR TRANSFERSTHE PRODUCT, WHICHEVER FIRST OCCURS AND IN NO EVENT SHALL AIR KING'S LIABILITY UNDER ANY EXPRESS OR IMPLIED WARRANTYINCLUDE (I) INCIDENTAL OR CONSEQUENTIAL DAMAGES FROM ANY CAUSE WHATSOEVER, OR (II) REPLACMENT OR REPAIR OF ANY HOUSEFUSES, CIRCUIT BREAKERS OR RECEPTACLES. NOTWITHSTANDING ANYTHING TO THE CONTRARY, .IN NO EVENT SHALL AIR KING'SLIABILITY UNDER ANY EXPRESS OR IMPLIED WARRANTY EXCEED THE PURCHASE PRICE OF THE PRODUCT AND ANY SUCH LIABILITY SHALLTERMINATE UPON THE EXPIRATION OF THE WARRANTY PERIOD.Some states and provinces do not allow limitations on how long an implied warranty lasts, or the exclusion or limitation of incidental or consequential damages,so these exclusions or limitations may not apply to you. This warranty gives you specific legal rights. You may also have other rights which vary from state tostate and province to province.Proof of purchase is required before a warranty claim will be accepted.

New 6/07 4 2085456