TECNOLOGIE PER LECOLOGIA
Via Calabria, 8 20017 Rho MI
Tel. +39 02 93506232 +39 02 93506242 Telefax 02-93509269
E-Mail [email protected] Sito web www.ecogas-srl.com
Codice Fiscale e Partita IVA 10046680152 C.C.I.A.A. 1338844 -
Trib. 305043/7682/43
Capitale Sociale 10.400,00
Certificato N 091768A
HTF-LU High Temperature Flare Landfill Biogas Unit
Our technology applied at landfill site consist in the
extraction of biogas continuously produced by the digestion of
municipal solid waste deposited. This biogas is manifested for many
years even after the completion and subsequent closure of the
landfill. If not extracted and controlled tends to seek ways out of
the surface of the landfill or search other preferential pathways
in the subsoil, in the case of landfills not perfectly sealed.
These two phenomena cause, the first manifestations of unpleasant
odors, and the second, danger situations for settlements
surrounding the landfill.Since 1990, the ECOGAS SRL is active in
this area, always with new technologies, creating turnkey systems
that avoid these faults. There are various types of installations
according to the characteristics of the landfill and specific
needs.
The Ecogas srl HTF-LU unit is specifically designed for the
extraction and combustion of biogas from landfill. The unit is
supplied completely pre-assembled with all necessary components as
to minimize the operations of assembly on site.
All components in contact with the biogas and the flare are made
of stainless steel so as to eliminate any phenomenon of internal
corrosion. Even the blower is made with specially treated materials
and suitable for biogas.
ECOGAS - HTF-LU unit is equipped with ECOGAS GECO high
temperature flares, internally coated with refractory insulation,
and are equipped with main burner for biogas and pilot ignition
burner with high energy electrical ignitor and UV flame detection
system.
This type of flare is designed in order to obtain an high
combustion efficiency and consequently CO and NOx very low emission
values, considerably beneath the limits required by all the current
European laws. The combustion temperature up to 1200 degree C, the
constant monitoring and automatic regulation of the temperature
ensures the optimum flare working in any conditions. The methane
amount in biogas can range from 20% to 70% (in volume) and the
regulation range of the flow from 5 to 1; it is possible to work
even with higher ranges but to detriment of the combustion
efficiency. The flares are equipped with Low Nox gas burner whose
geometry ensures an excellent mixing of biogas and combustion air.
An electrical command panel board automatically manages all the
controls necessary for a correct HTF-LU unit working.
Data Sheet HFT-LU rev. 2
TECNOLOGIE PER LECOLOGIA
Via Calabria, 8 20017 Rho MI
Tel. +39 02 93506232 +39 02 93506242 Telefax 02-93509269
E-Mail [email protected] Sito web www.ecogas-srl.com
Codice Fiscale e Partita IVA 10046680152 C.C.I.A.A. 1338844 -
Trib. 305043/7682/43
Capitale Sociale 10.400,00
Certificato N 091768A
TECHNICAL SPECIFICATIONS MAIN FEATURE : Automatic ignition
Ignition pilot burner High energy ignition Turn down 1:5 Automatic
temperature controller Arrestor filter Combustion temperature
1000-1200C Residence time 0.3 sec. High combustion efficiency Low
sound pressure level Combustion range 25-60% Electrical protection
IP 65 Power supply: 3x400/230/N/PE 50 Hz Condensate separation tank
included Construction inox
SAFETY DEVICES : UV control flame Flame arrestor Shut off valves
Ex execution Thermal control for motor Continuous control of
combustion temperature
GENERAL SPECIFICATION : Complete range size from 50 to 3000
Nmc/h PLC controller Ex execution according EN 60079 Standard
blower p 150-300 mBar IP 65 protection for control panel with
double door
OPTIONALS : Silenced and ventilated containerized extraction
unit CH4-O2-CO2-H2S Biogas Analysis System Automatic control of the
suction pressure Gas flow rate measurements Energy recovery
connection Skid mounted execution
BENEFITS : Easy installation Automatic operation Minimal
operator intervention Low investment
QUALITY - Certification BS/EN/ISO 9001:2000. The brand ECOGAS,
known and appreciated throughout the world, ensures quality at the
highest level and is certified in all areas of production according
to the standard ISO 9001:2000. Ecogas certified its quality system
according to ISO 9001 in March 2000 and subsequently to EN ISO
9001:2008 in December 2009. The QSM Certificate N 091768A is issued
by ACM Limited for the following activities: Design, construction,
installation, marketing systems for combustion, for the treatment
of water, the reclamation of landfills, and chemical and
petrochemical plants. SOA Certification In December 2011, the
company Bentley SOA has released CERTIFICATE OF QUALIFICATION TO
THE EXECUTION OF PUBLIC WORKS for categories OG9 and OG12.
Other ECOGAS SRL products :
- Reclamation plants landfills - Biogas extraction plants
- Biogas plants with energy recovery and cogeneration
- Biogas flares - Dehumidification systems
- SCADA systems with PLC / PC - Gravel filters
- Forced draft burners - Smokeless flares with air or steam
- Low-nox burners
Data Sheet HFT-LU rev. 2
