Feel the differenceFordRangerOwner's handbook

The information contained in this publication was correct at the time of going to print. In the interest ofdevelopment the right is reserved to change specifications, design or equipment at any time withoutnotice and without incurring any obligations. This publication, or part thereof, may not be reproducednor translated without our approval. Errors and omissions excepted.

© Ford Motor Company 2010

All rights reserved.

Part number: (CG3350en) 06/2010 20100720143543b

E108837

IntroductionAbout this handbook................................5Symbols glossary......................................5Parts and accessories..............................6

Quick startQuick start...................................................7

Child safetyChild seats................................................12Child seat positioning..............................13Booster cushions.....................................14Child safety locks.....................................15

Occupant protectionPrinciple of operation..............................16Fastening the seat belts..........................17Using seat belts during pregnancy.......18

Keys and remote controlsGeneral information on radiofrequencies...........................................19

Changing the remote controlbattery....................................................19

LocksLocking and unlocking...........................20

Engine immobiliserPrinciple of operation..............................22Coded keys.............................................22Arming the engine immobiliser.............22Disarming the engine immobiliser........22

AlarmPrinciple of operation..............................23Arming the alarm.....................................23Disarming the alarm................................23

SteeringwheelAdjusting the steering wheel.................24

Wipers andwashersWindscreen wipers.................................25Windscreen washers.............................25Checking the wiper blades...................25Changing the wiper blades...................26

LightingLighting control........................................27Front fog lamps.......................................27Rear fog lamps........................................27Headlamp levelling..................................28Hazard warning flashers........................28Direction indicators.................................28Interior lamps...........................................29Changing a bulb......................................29Bulb specification chart..........................34

Windows andmirrorsElectric windows.....................................35Exterior mirrors........................................36Electric exterior mirrors..........................36Rear quarter windows............................37

InstrumentsGauges.....................................................38Warning lamps and indicators..............44Audible warnings and indicators...........47

Climate controlPrinciple of operation..............................48Air vents....................................................48Manual climate control...........................48Heated windows and mirrors...............53

SeatsSitting in the correct position.................55

1

Table of contents

Front seats...............................................55Head restraints........................................56Rear seats................................................57Heated seats...........................................58

Convenience featuresClock.........................................................59Instrument lighting dimmer...................59Cigar lighter..............................................59Ashtray......................................................59Auxiliary power sockets.........................59Cup holders.............................................60Glove box.................................................60Storage compartments..........................61Auxiliary input (AUX IN) socket...............61

Starting the engineGeneral information................................62Ignition switch..........................................62Steering wheel lock................................62Starting a diesel engine..........................62Switching off the engine........................63

Fuel and refuellingSafety precautions..................................64Fuel quality - Diesel.................................64Catalytic converter..................................64Fuel filler flap.............................................65Refuelling..................................................65Technical specifications.........................65

TransmissionManual transmission...............................67All-wheel drive (AWD).............................67Automatic transmission..........................70

BrakesPrinciple of operation..............................72Hints on driving with ABS.......................72

Parking brake...........................................72

Parking aidPrinciple of operation..............................73Using the parking aid..............................73

Load carryingGeneral information................................75Rear loadspace hatches........................75Load retaining fixtures............................75Roof racks and load carriers.................76

TowingTowing a trailer.........................................78Detachable tow ball................................79

Driving hintsGeneral driving points............................82Running-in................................................82Cold weather precautions.....................82Reduced engine performance.............82

Emergency equipmentFirst aid kit.................................................83Warning triangle......................................83

FusesFuse box locations..................................85Changing a fuse......................................86Fuse specification chart.........................87

Vehicle recoveryTowing points...........................................91Towing the vehicle on four wheels.......91Transporting the vehicle.........................92

MaintenanceGeneral information................................93Opening and closing the bonnet..........94

2

Table of contents

Engine compartment overview - 2.5LDuratorq-TDCi (WL) Diesel/3.0LDuratorq-TDCi (WL) Diesel................95

Engine oil check......................................96Engine coolant check.............................97Power steering fluid check....................97Brake and clutch fluid check.................98Draining the fuel filter water trap...........98Washer fluid check.................................98Technical specifications.........................99

Vehicle careCleaning the exterior.............................101Cleaning the interior...............................101Repairing minor paint damage............102

Vehicle batteryBattery care............................................103Using booster cables............................103

Wheels and tyresGeneral information..............................105Changing a road wheel........................105Tyre care..................................................110Using winter tyres..................................110Using snow chains..................................111Technical specifications.........................111

Vehicle identificationVehicle identification plate.....................112Vehicle identification number (VIN)......112

Technical specificationsTechnical specifications........................113

Audio introductionImportant audio information................122

Audio unit overviewAudio unit overview...............................123

Audio systemsecuritySecurity code.........................................127Lost security code.................................127Entering a security code......................127Incorrect security code........................128

Audio unit clock and datedisplays

Setting the clock on the audio unit.....129

Audio unit operationOn/off control.........................................130Volume control.......................................130Station tuning control............................130Station preset buttons..........................130Audio menu control..............................130Waveband button..................................131Autostore control...................................131Traffic information control.....................131

Audio unitmenusAutomatic volume control....................133Alternative frequencies.........................133Priority programme type (PTY)...........133

Compact disc playerLoading compact discs........................135Ejecting compact discs........................135Ejecting multiple compact discs ........136Compact disc playback.......................136Compact disc selection.......................136Track selection.......................................137Fast forward/reverse............................137Shuffle/random......................................137Repeat compact disc tracks...............137MP3 file playback..................................138MP3 display options..............................140

3

Table of contents

Auxiliary input (AUX IN)socket

Auxiliary input (AUX IN) socket.............141

Audio systemcareAntenna...................................................142

Audio troubleshootingAudio troubleshooting..........................143

AppendicesElectromagnetic compatibility.............144

4

Table of contents

ABOUT THISHANDBOOK

Thank you for choosing Ford. Werecommend that you take some time toget to know your vehicle by reading thishandbook. Themore that you knowaboutit, the greater the safety and pleasure youwill get from driving it.

WARNING

Always drive with due care andattentionwhen using and operatingthe controls and features on your

vehicle.

Note: This handbook describes productfeatures and options available throughoutthe range, sometimes even before theyare generally available. It may describeoptions not fitted to your vehicle.

Note: Some of the illustrations in thishandbook may be used for differentmodels, so may appear different to yourvehicle. However, the essentialinformation in the illustrations is alwayscorrect.

Note: Always use and operate yourvehicle in line with all applicable laws andregulations.

Note: Pass on this handbook whenselling your vehicle. It is an integral part ofthe vehicle.

This vehicle has received theendorsement of TÜV, the accreditedinternational testing organisation, for itsallergy-friendly properties.

All materials used in the manufacture ofthe interior of this vehicle meet strictrequirements of the TÜV TOXPROOFCriteria Catalogue for Vehicle Interiors byTÜV Produkt and Umwelt GmbH and aredesigned to minimize the risk of allergicreactions.

Additionally an efficient pollen filterprotects the passengers against allergenparticles in the outdoor air.

For more information, contact TÜV atwww.tuv.com.

SYMBOLSGLOSSARY

Symbols in this handbook

WARNING

You risk death or serious injury toyourself and others if you do notfollow the instructions highlighted

by the warning symbol.

CAUTION

You risk damaging your vehicle if youdo not follow the instructionshighlighted by the caution symbol.

Symbols on your vehicle

When you see these symbols, read andfollow the relevant instructions in thishandbook before touching or attemptingadjustment of any kind.

5

Introduction

PARTSANDACCESSORIES

Genuine Ford parts and accessories havebeen designed specifically for yourvehicle. Unless we have specificallystated, we have not tested non-Fordparts and accessories and, therefore, wewill not guarantee that they are suitablefor your vehicle.We recommend that youask your Ford Dealer for advice on partsand accessories suitable for your vehicle.

6

Introduction

QUICKSTART

Instrument panel overview - LHD

DA B E H IGFC J

PQE78401

TRS O N M LU

K

V

7

Quick start

Instrument panel overview - RHD

IH J K E F CDG B

SQPOTL NM UR

A

E78402V

Headlamp levelling control. See Headlamp levelling (page 28).A

Instrument lighting dimmer.B

Air vents. See Air vents (page 48).C

Multifunction lever. See Direction indicators (page 28). See Lightingcontrol (page 27).

D

Instrument cluster. SeeGauges (page 38).E

Wiper lever. SeeWindscreenwipers (page 25).F

Audio unit. See Audio introduction (page 122).G

Inclinometer - pitch. SeeGauges (page 38).H

Hazard warning flasher switch. SeeHazardwarning flashers (page 28).I

Compass. SeeGauges (page 38).J

Inclinometer - roll. SeeGauges (page 38).K

8

Quick start

Heated rear window switch. See Heatedwindows andmirrors (page53).

L

Climate controls. SeeManual climate control (page 48).M

Cigar lighter and auxiliary power socket. SeeCigar lighter (page 59). SeeAuxiliary power sockets (page 59).

N

Parking brake. See Parking brake (page 72).O

Horn.P

Steeringwheel adjustment. SeeAdjustingthesteeringwheel (page 24).Q

Remote free-wheel switch. See All-wheel drive (AWD) (page 67).R

Parking aid switch. See Using the parking aid (page 73).S

Heated seats switch. See Heated seats (page 58).T

Engine warm-up switch. SeeManual climate control (page 48).U

Auxiliary input (AUX IN) socket. SeeAuxiliary input (AUXIN)socket (page141).

V

Instrument cluster

B CA

EF DE78487

TachometerA

SpeedometerB

Engine coolant temperature gaugeC

Fuel gaugeD

Tripmeter reset buttonE

Odometer and tripmeterF

SeeGauges (page 38).

9

Quick start

Warning lamps and indicators

ABS warning lamp

Airbag warning lamp

Brake system warning lamp

Engine warning lamp

Ignition warning lamp

Low fuel level warning lamp

Oil pressure warning lamp

Water-in-fuel indicator lamp

SeeWarning lampsandindicators(page 44).

Locking and unlocking

Rear doors - 4-door

E77757

B

C

A

Red markA

LockB

UnlockC

Rear doors - 4-door stretch cab

E77759

1

2

1. Open the front door.

2. Pull the lever.

10

Quick start

Tailgate

E77761

Auxiliary power sockets

E83679

CAUTION

If you use the auxiliary power socketwhen the engine is not running, thebattery may discharge.

Switch the ignition on to use the auxiliarypower socket.

11

Quick start

CHILDSEATS

E68916

WARNINGSSecure children that are less than150 centimetres tall or less than 12years of age in a suitable, approved

child restraint, in the rear seat.

Original text according to ECER94.01: ExtremeHazard!Donot usea rearward facing child restraint on

a seat protected by an air bag in front ofit!

Read and follow themanufacturer’sinstructions when you are fitting achild restraint.

Do not modify child restraints in anyway.

Do not hold a child on your lapwhenthe vehicle is moving.

Do not leave unattended children inyour vehicle.

If your vehicle has been involved inan accident, have the child restraintschecked by properly trained

technicians.

Note:Mandatory use of child restraintsvaries from country to country.

Only child restraints certified toECE-R44.03 (or later) have been testedand approved for use in your vehicle. Achoice of these are available from yourDealer.

Child restraints for differentmass groups

Use the correct child restraint as follows:

Baby safety seat

E68918

Secure children that weigh less than 13kilograms in a rearward facing baby safetyseat (Group 0+) in the rear seat.

12

Child safety

Child safety seat

E68920

Secure children that weigh between 13and 18 kilograms in a child safety seat(Group 1) in the rear seat.

CHILDSEATPOSITIONING

Child seat positions

Mass group categories

Seating positions

3210+0

22 - 36kg15 - 25 kg9 - 18 kgUp to 13kg

Up to 10kg

Boosterseat orcushion

Boosterseat orcushion

Childsafetyseat

Babysafetyseat

Babysafetyseat

XXXXXFront passenger seatwith airbag

UUUUUFront passenger seatwithout airbag

UUUUURear passenger seat -left-hand and right-hand

XXXXXRear passenger seat -centre

X Not suitable for children in this mass group.

U Suitable for universal category child restraints approved for use in this mass group.

13

Child safety

BOOSTERCUSHIONS

WARNINGSDo not install a booster seat or abooster cushion with only the lapstrap of the seat belt.

Do not install a booster seat or abooster cushionwith a seat belt thatis slack or twisted.

Do not put the seat belt under yourchild’s arm or behind its back.

Do not use pillows, books or towelsto boost your child’s height.

Make sure that your children sit inan upright position.

Secure children that weigh morethan 15 kilograms but are less than150 centimetres tall in a booster

seat or a booster cushion.

CAUTION

When using a child seat on a rearseat, make sure that the child seatrests tightly against the vehicle seat.

It may be necessary to lift or remove thehead restraint. See Head restraints(page 56).

Booster seat (Group2)

E70710

We recommend that you use a boosterseat that combines a cushion with abackrest instead of a booster cushiononly. The raised seating position will allowyou to position the shoulder strap of theadult seat belt over the centre of yourchild’s shoulder and the lap strap tightlyacross its hips.

Booster cushion (Group3)

E68924

14

Child safety

CHILDSAFETY LOCKS

A

B

E77760

OnA

OffB

WARNING

You cannot open the doors fromthe inside if you have put the childsafety locks on.

15

Child safety

PRINCIPLEOFOPERATION

Airbags

WARNINGSDo not modify the front of yourvehicle in any way. This couldadversely affect deployment of the

airbags.

Original text according to ECER94.01: ExtremeHazard!Donot usea rearward facing child restraint on

a seat protected by an air bag in front ofit!

Wear a seat belt and keep sufficientdistance between yourself and thesteering wheel. Only when you use

the seat belt properly, can it hold you in aposition that allows the airbag to achieveits optimum effect. See Sitting in thecorrect position (page 55).

Have repairs to the steering wheel,steering column, seats, airbags andseat belts carried out by properly

trained technicians.

Keep the areas in front of theairbags free from obstruction. Donot affix anything to or over the

airbag covers.

Do not poke sharp objects intoareas where airbags are fitted. Thiscould damage and adversely affect

deployment of the airbags.

Use seat covers designed for seatswith side airbags. Have these fittedby properly trained technicians.

Note: You will hear a loud bang and seea cloud of harmless powdery residue if anairbag deploys. This is normal.

Note: The front passenger airbagprotects both positions of a double seat.

Note: Only wipe airbag covers with adamp cloth.

Driverandfrontpassengerairbags

E68581

30 o

30 o

The driver and front passenger airbagswill deploy during significant frontalcollisions or collisions that are up to 30degrees from the left or the right. Theairbags will inflate within a fewthousandths of a second and deflate oncontact with the occupants, thuscushioning forward body movement.During minor frontal collisions, overturns,rear collisions and side collisions, the driverand front passenger airbags will notdeploy.

16

Occupant protection

Side airbags

E68905

Side airbags are fitted inside the seatbackof the front seats. A label indicates thatside airbags are fitted to your vehicle.

The side airbags will deploy duringsignificant lateral collisions. Only the airbagon the side affected by the collision willdeploy. The airbagswill inflatewithin a fewthousandths of a second and deflate oncontact with the occupants, thusproviding protection for the head and ribareas. During minor lateral collisions,overturns, front collisions and rearcollisions, the side airbags will not deploy.

Seat belts

WARNINGSWear a seat belt and keep sufficientdistance between yourself and thesteering wheel. Only when you use

the seat belt properly, can it hold you in aposition to achieve its optimum effect.See Sitting in the correct position(page 55).

Use a seat belt for only one person.

Use the correct buckle for each seatbelt.

WARNINGSDo not use a seat belt that is slackor twisted.

Do notwear thick clothing. The seatbeltmust fit tightly around your bodyto achieve its optimum effect.

Position the shoulder strap of theseat belt over the centre of yourshoulder and position the lap strap

tightly across your hips.

Seat belt pretensioners have a lowerdeployment threshold than the airbags.During minor collisions, it is possible thatonly the seat belt pretensioner will deploy.

Status after a collision

WARNING

Seat belts subjected to strain, as aresult of an accident, should berenewed and the anchorages

checked by a properly trained technician.

FASTENINGTHESEATBELTS

E68584

17

Occupant protection

E78560

WARNING

Insert the tongue into the buckleuntil you hear a distinct click. Youhave not fastened the seat belt

properly if you do not hear a click.

Pull the seat belt out steadily. It may lockif you pull it sharply or if the vehicle is on aslope.

Press the red button on the buckle torelease the seat belt. Let it retractcompletely and smoothly.

USINGSEATBELTSDURINGPREGNANCY

E68587

WARNING

Position the seat belt correctly foryour safety and that of your unbornchild. Do not use only the lap strap

or the shoulder strap.

Position the lap strap comfortably acrossyour hips and low beneath your pregnantabdomen. Position the shoulder strapbetween your breasts, above and to theside of your pregnant abdomen.

18

Occupant protection

GENERALINFORMATIONONRADIO FREQUENCIES

CAUTION

The radio frequency used by yourremote control can also be used byother short distance radio

transmissions (e.g. amateur radios,medical equipment,wirelessheadphones,remote controls and alarm systems). Ifthe frequencies are jammed, you will notbe able to use your remote control. Youcan lock and unlock the doors with thekey.

Note: You could unlock the doors if youpress the buttons on the remote controlunintentionally.

The operating range between yourremote control and your vehicle variesdepending on the environment.

CHANGINGTHEREMOTECONTROLBATTERY

Make sure that you dispose of oldbatteries in an environmentally friendlyway. Seek advice from your local authorityregarding recycling.

E93716

1

E93717

2

E66527

3

E93718

4

19

Keys and remote controls

LOCKINGANDUNLOCKING

Locking and unlocking thedoorswith the key

E77763

A

B

A

B

UnlockA

LockB

Locking and unlocking thedoorswith the remote control

A

B

E77766

LockA

UnlockB

Press the lock button once.

20

Locks

Locking and unlocking thedoorswith the handles

Front doors - all vehicles

E77757

B

C

A

Red markA

LockB

UnlockC

If you see the red mark, the door islocked.

Rear doors - 4-door

E77757

B

C

A

Red markA

LockB

UnlockC

If you see the red mark, the door islocked.

Rear doors - 4-door stretch cab

E77759

1

2

1. Open the front door.2. Pull the lever.

Tailgate

E77761

21

Locks

PRINCIPLEOFOPERATION

The engine immobiliser is a theftprotection system that prevents someonefrom starting the engine with anincorrectly coded key.

CODEDKEYS

Note:Do not shield your keys withmetalobjects. This may prevent the receiverfrom recognising your key as a valid one.

Note: Have all of your remaining keyserased and recoded if you lose a key. Askyour dealer for further information. Havereplacement keys recoded togetherwithyour existing keys.

If you lose a key, you can obtain areplacement from your Ford Dealer. Ifpossible, provide them with the keynumber from the tag provided with theoriginal keys. You can also obtainadditional keys from your Ford Dealer.

ARMINGTHEENGINEIMMOBILISER

The engine immobiliser is armedautomatically a short time after you haveswitched the ignition off.

The indicator in the instrument cluster willflash to confirm that the system isoperating.

DISARMINGTHEENGINEIMMOBILISER

The engine immobiliser is disarmedautomaticallywhen you switch the ignitionon with a correctly coded key.

The indicator in the instrument cluster willcomeon for approximately three secondsand then go out. If the indicator stays onfor one minute or flashes forapproximately one minute and thenrepeatedly at irregular intervals, your keyhas not been recognised. Remove thekey and try again.

If you are unable to start the engine witha correctly coded key, this indicates amalfunction. Have the immobiliserchecked immediately.

22

Engine immobiliser

PRINCIPLEOFOPERATION

All vehicles

If the alarm is triggered, the alarm hornswill sound and the hazardwarning flasherswill flash for 25 seconds. If the cause ofthe alarm being triggered has beenremoved, the alarm will return to itsprevious armed state. If the cause has notbeen removed, the alarmhornswill soundand the hazard warning flashers will flashuntil a door is unlocked using a key or theremote control.

Vehicleswithaperimeteralarm

The perimeter alarm is a deterrent againstunauthorised access to your vehiclethrough the doors and the bonnet.

The perimeter alarm will be triggered ifsomeone:• opens a door.

• opens the bonnet.

• attempts to start the engine with anincorrectly coded key.

ARMINGTHEALARM

Perimeter alarm

The alarm is armed 20 seconds after youhave locked the doors. This delay allowsyou to close any doors or the bonnetwithout triggering the alarm.

Partial arming

Lock the doors with the key. SeeLocking and unlocking (page 20).

Full arming

Lock the doors with the remote control.SeeLockingandunlocking (page20).

DISARMINGTHEALARM

Perimeter alarm

Disarmand silence the alarmby unlockingthe doors with the key, switching theignition on with a correctly coded key orunlocking the doors with the remotecontrol. See Locking and unlocking(page 20).

23

Alarm

ADJUSTINGTHESTEERINGWHEEL

WARNING

Never adjust the steering wheelwhen the vehicle is moving.

E78214

Release the locking lever to adjust theheight of the steering wheel.

Return the lever to its original position tosecure the wheel.

Make sure that you are sitting in thecorrect position. See Sitting in thecorrect position (page 55).

24

Steeringwheel

WINDSCREENWIPERS

A

BCD

E113704

Single wipeA

Intermittent wipeB

Normal wipeC

High speed wipeD

Intermittentwipe

C

A

B

E113705

Long wipe intervalA

Intermittent wipeB

Short wipe interval.C

WINDSCREENWASHERS

E113706

WARNING

Do not operate the windscreenwashers for more than 10 secondsor when the reservoir is empty.

CHECKINGTHEWIPERBLADES

E66644

Run the tip of your fingers over the edgeof the blade to check for roughness.

Clean the wiper blade lips with waterapplied with a soft sponge.

25

Wipers andwashers

CHANGINGTHEWIPERBLADES

E93783

1

2

E93784

3

5

4

E93785

6

E93786

Install in the reverse order.

26

Wipers andwashers

LIGHTINGCONTROL

Lighting control positions

C

A

B

E113707

OffA

Side and tail lampsB

HeadlampsC

Main and dipped beam

E113708

Pull the lever fully towards the steeringwheel to switch between main anddipped beam.

Headlamp flasher

Pull the lever slightly towards the steeringwheel.

FRONT FOGLAMPS

E113709

WARNING

Only use the front fog lamps whenvisibility is considerably restricted byfog, snow or rain.

Note: You cannot switch the front foglamps on unless you have switched theheadlamps on.

REARFOGLAMPS

E113710

WARNINGSOnly use the rear fog lamps whenvisibility is restricted to less than 50metres (164 feet).

Do not use the rear fog lampswhenit is raining or snowing and visibilityis more than 50 metres (164 feet).

Note: You cannot switch the rear foglamps on unless you have switched theheadlamps on.

27

Lighting

HEADLAMPLEVELLING

E78244

Without headlamp levellingA

With headlamp levellingB

You can adjust the level of the headlampbeams according to the vehicle load.

E78243

A

B

Raised headlamp beamsA

Lowered headlamp beamsB

Set the headlamp levelling control to zerowhen your vehicle is unloaded. Set it toprovide illumination between 35 and 100metres when your vehicle is partially orfully loaded.

HAZARDWARNINGFLASHERS

E71943

DIRECTION INDICATORS

E113711

28

Lighting

INTERIOR LAMPS

Courtesy lamp

A

B C

E92390

B

C A

E92415

OnA

Door contactB

OffC

Vehicleswith double locking

If you set the switch to position B, theinterior lamps will stay on for a short timeafter you close the doors. They will go offimmediately when you switch the ignitionon.

When you switch the ignition off, theinterior lamps will come on. They will gooff automatically after a short time.

If you leave a door open, the interior lampswill go off automatically after 30 minutes.To switch them back on, switch theignition on for a short time.

Reading lamps

E92391

CHANGINGABULB

WARNINGSSwitch the lights and the ignition off.

Let the bulb cool down beforeremoving it.

CAUTIONSDo not touch the glass of the bulb.

Only fit bulbs of the correctspecification. See Bulbspecification chart (page 34).

Note:Youwill need to detach thewasherfluid reservoir to change the headlampbulbs.

Note: The following instructions describehow to remove the bulbs. Fitreplacements in the reverse order unlessotherwise stated.

29

Lighting

Headlampmain and dippedbeam

E78333

2

E78334

3

5

6

4

1. Open thebonnet. SeeOpeningandclosing the bonnet (page 94).

2. Detatch the washer fluid reservoir.3. Disconnect the electrical connector.4. Release the clip.5. Remove the cover.6. Remove the bulb.

Side lamps and front directionindicators

1

E78336

E783372

3

32

B

A

Direction indicatorA

Side lampB

1. Detach the wheel-arch lining andgently pull back.

2. Remove the bulb and the bulb holder.3. Remove the bulb.

30

Lighting

Front fog lamps

1

2

E78335

Note:You cannot separate the bulb fromthe bulb holder.

1. Disconnect the electrical connector.2. Turn the bulb holder anti-clockwise

and remove it.

Side repeaters

E78338

21

Note:You cannot separate the bulb fromthe bulb holder.

1. Slide the lens to the right and removeit.

2. Disconnect the electrical connector.

Exteriormirror lamps

A

BE92640

Side repeater lampA

Approach lampB

Note: ItemsA andB are not serviceableitems, please consult your dealer if thesefail.

Rear lamps

TypeA

2 3

E78339

31

Lighting

B

A

4

C

E78340

5

Tail and brake lampA

Direction indicatorB

Reversing and fog lampC

1. Open the tailgate.2. Remove the screws.3. Remove the rear lamp.4. Turn the bulb holder anti-clockwise

and remove it.5. Remove the bulb.

TypeB

1

3

2

A B C

E83642

Reversing lampA

Tail and brake lampB

Direction indicatorC

1. Remove the screws.2. Remove the lens.3. Remove the bulb.

Rear fog lamp

E78341

12

3

1. Remove the screws.2. Remove the lens.3. Remove the bulb.

32

Lighting

Number plate lamp

E783491

3

2

1. Remove the screws.2. Remove the lens.3. Remove the bulb.

Front interior lamps

E78350

1

2

1. Remove the lens.2. Remove the bulb.

Front reading lamps

Stretch and double cab

E78351

2

1

1. Remove the lens.2. Remove the bulb.

Rear interior lamps

E83672

1

2

1. Carefully prise out the lamp.2. Remove the bulb.

33

Lighting

Footwell lamps

1

2

E83673

1. Turn the bulb holder anti-clockwiseand remove it.

2. Remove the bulb.

BULBSPECIFICATIONCHART

Specification (Watts)Bulb

55/60Headlamp main and dipped beam

21Front direction indicator

5Side lamp

55Front fog lamp *

5Side repeater

21Rear direction indicator

5/21Tail and brake lamp

21Reversing lamp

21Rear fog lamp

5Number plate lamp

10Interior lamp

10Reading lamp

10Stepwell lamp

* Bulb replacement is not possible as thebulb is an integral part of the unit. The foglamp unit has to be changed.

34

Lighting

ELECTRICWINDOWS

WARNING

Donot operate the electricwindowsunless they are free fromobstruction.

Switch on the ignition to operate theelectric windows.

Driver’s door switches

You can operate all the windows with theswitches on the door trim panel of thedriver’s door.

B

A

E78353

CloseA

OpenB

Front and rear passengers’door switches

B

A

E78355

CloseA

OpenB

Opening and closing thewindows automatically

Press the open button briefly. Press or liftit again to stop the window.

Safety switch for thepassengerwindows

Note: You can always operate the rearwindows from the driver’s door.

E78354

A switch on the door trim panel of thedriver’s door disables the passengerelectric window switches.

35

Windows andmirrors

EXTERIORMIRRORS

WARNING

Do not overestimate the distanceof the objects that you see in theconvex mirror. Objects seen in

convex mirrors will appear smaller andfurther away than they actually are.

Manual foldingmirrors

Folding

Push themirror towards the doorwindowglass.

Unfolding

Make sure that you fully engage themirrorin its support when returning it to itsoriginal position.

ELECTRIC EXTERIORMIRRORS

E78358

B

A

C

Left-hand mirrorA

OffB

Right-hand mirrorC

E

G

FD

E78359

UpD

RightE

DownF

LeftG

The electric exteriormirrors are fittedwitha heating element that will defrost ordemist the mirror glass. See Heatedwindows andmirrors (page 53).

Electric foldingmirrors

E113715

To fold and unfold the mirrors, brieflypress the switch. If the switch is pressedagain while the mirrors are moving, theywill stop and reverse the direction ofmovement.

36

Windows andmirrors

REARQUARTERWINDOWS

E66498

Pull the lever outwards to open thewindow. Press the lever in the middle toengage it in its catch. Pull the lever in themiddle to close the window. Push itbackwards until it engages in its catch.

37

Windows andmirrors

GAUGES

B CA

EF DE78487

TachometerA

SpeedometerB

Engine coolant temperaturegauge

C

Fuel gaugeD

Tripmeter reset buttonE

Odometer and tripmeterF

Engine coolant temperaturegauge

Shows the temperature of the enginecoolant. At normal operating temperature,the needle will remain in the centresection.

CAUTION

Do not restart the engine until thecause of overheating has beenresolved.

If the needle moves towards the red line,the engine is overheating. Stop theengine, switch the ignition off anddetermine the cause once the enginehas cooled down. See Enginecoolant check (page 97).

Fuel gauge

The arrow adjacent to the fuel pumpsymbol tells you on which side of yourvehicle the fuel filler cap is located.

Odometer and tripmeter

E79253

E79254

The tripmeter can record more than onejourney. Press button E to switchbetween journeyA, journeyB andODO.

The tripmeter will register the distance ofan individual journey. Press and holdbutton E to reset the tripmeter.

38

Instruments

Inclinometer and compass

E D

A B C

E83654

Pitch inclinometerA

CompassB

Roll inclinometerC

Outside air temperatureD

Interior temperatureE

Pitch inclinometer

The pitch inclinometer indicates the foreand aft angle of the vehicle from thehorizontal, measured in degrees.

Compass

The compass indicates the direction ofthe vehicle by displaying an arrowindicator and compass heading.

Roll inclinometer

The roll inclinometer indicates the side toside angle of the vehicle from thehorizontal, measured in degrees.

Programmingtheinclinometerand compass

Mainmenu

Overviewofthemainmenudisplays

39

Instruments

E83685

The various sub-menus are accessedfrom the main menu.

Entering the programmemode

A

B

E83655

1. Press and hold buttons A and B forfour seconds or more.

2. Press buttonA to select the item thatyou want to adjust.

Setting up pitch and roll

Note:Make sure that your vehicle is onlevel ground.

1. Press button A to select PITCH setup mode.

2. Press button B to set zero degrees.

3. Press buttonA to selectROLL set upmode.

4. Press button B to set zero degrees.

5. Exit the programme mode.

Calibrating the compass

Note:Make sure that your vehicle is onlevel ground.

1. Press button A to select CAL set upmode.

2. Press button B to activate CAL setup mode.

3. Drive the vehicle with full steering lockon for two complete circles.

4. Press button B to set the calibration.

5. Exit the programme mode.

Adjusting the declination angle

Note:Make sure that your vehicle is onlevel ground.

1. Press button A to select dEC set upmode.

2. Press button B to activate dEC setup mode.

3. Enter your correct declination angle.See declination table.

4. Press button B to change the digitfrom right to left.

5. Press button A to change the figure(at the 1st and 2nd digit).

40

Instruments

6. Press button A to change to plus orminus (at the 3rd digit).

7. Press button B to set the declinationangle.

8. Exit the programme mode.

Exit the programmemode

Note: If no buttons are pressed for aperiod of 15 seconds or more theprogrammingmodewill automatically exit.

Press button B when PGM is displayed.

Declination table

DeclinationLongitudeLatitudeCityCountry

03.136.8AlgerAlgeria

-1-0.635.7OranAlgeria

-14.451.2AntwerpBelgium

-14.350.8BrusselsBelgium

-13.751GentBelgium

05.650.6LiegeBelgium

-14.950.5NamurBelgium

316.649.2BrnoCzech

213.449.8PlzenCzech

214.550.1PragueCzech

110.256.2ArhusDenmark

212.655.7CopenhagenDenmark

110.455.4OdenseDenmark

110.657.7SkagenDenmark

621.460.6HelsinkiFinland

1029.862.6JoensuuFinland

825.565OuluFinland

723.861.5TampereFinland

622.360.5TurkuFinland

925.766.5RovaniemiFinland

113.352.5BerlinGermany

41

Instruments

DeclinationLongitudeLatitudeCityCountry

18.853BremenGermany

06.751.2DusseldorfGermany

2850FrankfurtGermany

11053.5HamburgGermany

211.648.3MunichGermany

19.248.7StuttgartGermany

323.738AthensGreece

322.439.6LarisaGreece

322.940.6ThessalnikiGreece

-172264.2ReykjavikIceland

-6-8.551.9CorkIreland

-6-7.652.6DublinIreland

-7-953.3GalwayIreland

111.344.5BolognaItaly

110.946.4CagliariItaly

111.343.8FlorenceItaly

19.243.5MilanItaly

214.340.8NaplesItaly

213.438.1PalermoItaly

212.541.9RomeItaly

215.337.1SyracuseItaly

213.845.6TriesteItaly

17.745.1TurinItaly

212.345.4VeniceItaly

-14.952.4AmsterdamHolland

0651.6GroningenHolland

-14.551.9RotterdamHolland

42

Instruments

DeclinationLongitudeLatitudeCityCountry

05.951.5The HagueHolland

-25.360.4BergenNorway

110.859.9OsloNorway

61969.7TromasaNorway

110.463.4TrondheimNorway

-15.859StavangerNorway

-4-7.937FaroPortugal

-4-9.138.7LisbonPortugal

-4-8.542PortoPortugal

92652KurskRussia

1127.555.5MoscowRussia

1430.560St. PetersburgRussia

-2-3.743.4BarcelonaSpain

-2-3.343.3BilbaoSpain

-6-15.728La CorunaSpain

-2-3.740.4MadridSpain

-2-4.436.7MalagaSpain

-3-637.4SevillaSpain

-4-8.843.2ValenciaSpain

21257.7GothenburgSweden

722.265.6LuleaSweden

316.757.8MalmoSweden

314.763.2OstersundSweden

213.861.9StockholmSweden

620.363.8UmeaSweden

17.647.6BaselSwitzerland

07.546.9BernSwitzerland

43

Instruments

DeclinationLongitudeLatitudeCityCountry

06.246.2GenevaSwitzerland

06.746.5LausanneSwitzerland

18.647.4ZurichSwitzerland

428.938.6AdanaTurkey

432.939.9AnkaraTurkey

42941IstanbulTurkey

427.238.4IzmirTurkey

-6-5.954.6BelfastUnitedKingdom

-3-1.952.5BirminghamUnitedKingdom

-2-0.250.8BrightonUnitedKingdom

-4-3.251.5CardiffUnitedKingdom

-5-3.256EdinburghUnitedKingdom

-4-353.4LiverpoolUnitedKingdom

-3-0.151.5LondonUnitedKingdom

-4-2.253.5ManchesterUnitedKingdom

-5-5.554.4NewcastleUnitedKingdom

-4-4.150.4PlymouthUnitedKingdom

WARNINGLAMPSANDINDICATORS

The following warning lamps andindicators will come on briefly when youswitch the ignition on to confirm that thesystem is operational:• ABS warning lamp

• Airbag warning lamp

• Brake system warning lamp

• Door open warning lamp

• Engine warning lamp

• Ignition warning lamp

• Low fuel level warning lamp

• Oil pressure warning lamp

• Water-in-fuel indicator.

ABSwarning lamp

If it illuminates when you aredriving, this indicates amalfunction. You will continue

to have normal braking (without ABS).Have the system checked by a properlytrained technician as soon as possible.

44

Instruments

Airbagwarning lamp

If it illuminates while driving, thisindicates a malfunction. Havethis checked as soon as

possible.

Brake system lamp

It illuminates when the parkingbrake is engaged.

WARNING

Reduce your speed gradually andstop your vehicle as soon as it issafe to do so. Use your brakes with

care.

If it illuminateswhen you are driving, checkthat the parking brake is not engaged. Ifthe parking brake is not engaged, thisindicates amalfunction. Have the systemchecked by a properly trained technicianimmediately.

Door openwarning lamp

The door open warning lampwill come on when you switchthe ignition on if you have not

closed the doors, the bonnet or tailgateproperly.

Enginewarning lamp

If the engine warning lamp comes onwhen the engine is running, this indicatesa malfunction. If it flashes when you aredriving, reduce the speed of yourvehicle immediately. If it continues toflash, avoid heavy acceleration ordeceleration. The engine will continue torun but it will have limited power. Have thischecked immediately.

The engine warning lamp alsofunctions as a glow plugindicator lamp. See Starting

a diesel engine (page 62).

Ignitionwarning lamp

If the ignition warning lampcomesonwhen you are driving,switch off all unnecessary

electrical equipment and have thischecked immediately Have this checkedby an expert.

Low fuel level warning lamp

If the low fuel level warning lampcomes on, refuel as soon aspossible.

The arrow adjacent to the fuel pumpsymbol tells you on which side of yourvehicle the fuel filler cap is located.

Oil pressurewarning lamp

CAUTION

Do not resume your journey if the oilpressure warning lamp comes ondespite the oil level being correct.

Have this checked immediately.

If the oil pressure warning lampcomesonwhen you are driving,this indicates a malfunction.

Stop, and switch the engine off and checkthe engine oil level. See Engine oilcheck (page 96).

Water-in-fuel indicator lamp

Thewater-in-fuel indicator lampwill come on if there is excesswater in the fuel filter. Drain off

the water immediately. See Drainingthe fuel filterwater trap (page 98).

45

Instruments

Direction indicator

The direction indicator will flashwhen you use the directionindicators. A sudden increase in

the rate of flashing warns of a failed bulb.

Headlamp indicator

The headlamp indicator willcome on when you switch theheadlamp dipped beam or the

side and tail lamps on.

Main beam indicator

The main beam indicator willcome on when you switch theheadlamp main beam on. It will

flashwhen you use the headlamp flasher.

Front fog lamp indicator

The front fog lamp indicator willcome on when you switch thefront fog lamps on.

Rear fog lamp indicator

The rear fog lamp indicator lampwill come on when you switchthe rear fog lamps on.

Overdrive off (O/DOFF)indicator

E92387

The overdrive off (O/D OFF)indicator lamp will come onwhen you switch the overdrive

function off. See Automatictransmission (page 70).

Four-wheel drive indicator

The four-wheel drive indicatorlamp will come on when theall-wheel drive (AWD) lever is in

the 4H or 4L position. See All-wheeldrive (AWD) (page 67).

Remote freewheel (RFW)indicator

The remote free wheel (RFW)indicator lamp will come onwhen the all-wheel drive (AWD)

lever is in the 4H or 4L position. If itflashes when you are driving, reduce thespeed of your vehicle immediately. Switchoff the remote freewheel lockmechanismand engage two-wheel drive. SeeAll-wheel drive (AWD) (page 67).

Four-wheel drive low (4L)indicator

E92386

The four-wheel drive low (4L)indicator lamp will come onwhen the transfer shift switch is

in the 4L position. If it flashes when youare driving, stop your vehicle when it issafe to do so and select the neutralposition. See All-wheel drive (AWD)(page 67).

Vehicle speed alarm indicator

The vehicle speed alarmindicator lamp will come onwhen the vehicle exceeds

120km/h.

46

Instruments

AUDIBLEWARNINGSANDINDICATORS

Door openwarning

The door open warning chime will soundif you switch the ignition on and you havenot closed the doors.

Lights onwarning

The lights on warning chime will sound ifyou remove the ignition key and open anydoor before switching of the lights.

47

Instruments

PRINCIPLEOFOPERATION

Outside air

Keep the air intakes forward of thewindscreen free from obstruction (snow,leaves etc.) to allow the climate controlsystem to function effectively.

Recirculated air

CAUTION

Prolonged use of recirculated airmaycause the windows to mist up. If thewindows mist up, follow the settings

for defrosting and demisting thewindscreen.

The air currently in the passengercompartmentwill be recirculated. Outsideair will not enter the vehicle.

Heating

Heating performance depends on thetemperature of the engine coolant.

Air conditioning

Note: The air conditioning operates onlywhen the temperature is above 4ºC(39ºF).

Note: If you use the air conditioning, thefuel consumption of your vehicle will behigher.

Air is directed through the evaporatorwhere it is cooled. Humidity is extractedfrom the air to help keep thewindows freeof mist. The resulting condensation isdirected to the outside of the vehicle andit is therefore normal if you see a smallpool of water under your vehicle.

General information oncontrolling the interior climate

Fully close all the windows.

Warming the interior

Direct the air towards your feet. In cold orhumid weather conditions, direct someof the air towards thewindscreen and thedoor windows.

Cooling the interior

Direct the air towards your face.

AIR VENTS

E71942

MANUALCLIMATECONTROL

Warm-up system

1. Start the engine and allow it to idle.2. Press the switch to turn the warm-up

systemon and off. The indicator in theswitch will come on when thewarm-up system is operating.

48

Climate control

E92479

Note: The warm-up system will switchoff automatically when the engine coolanthas reached its operating temperature.However, the indicator in the switch willcontinue to be illuminated.

Note: If the coolant or ambienttemperature is already at operatingtemperature thewarm-up systemwill notoperate even if the switch is pressed andthe indicator in the switch is illuminated.

Note: The warm-up system may switchoff automatically if the accelerator pedalis pressed.

Air distribution control

B

CD

E

A

E78610

FootwellA

Footwell and windscreenB

WindscreenC

Face levelD

Face level and footwellE

You can set the air distribution control toany position between the symbols. Asmall amount of air is always directedtowards the windscreen.

Temperature control

E65966

ColdBlue

WarmRed

49

Climate control

Blower

E78609

OffO

Note: If you switch the blower off, thewindscreen may mist up.

Recirculated air

BA

E78611

Recirculating airA

Outside airB

Defrosting and demisting thewindscreen quickly

E78618

Close all of the air vents for maximumairflow to the windscreen.

50

Climate control

Heating the interior quickly

E78612

Ventilation

E78613

A

B

Face level and footwellA

Face levelB

Set the air distribution control to positionA or position B. Set the blower to anyposition. Open the air vents to suitindividual requirements.

51

Climate control

Air conditioning

Switching the air conditioning onand off

E78615

Press the blower control to switch the airconditioning on and off. The indicator inthe control will come on when the airconditioning is operating.

Coolingwith outside air

E78616

Switch the air conditioning on.

52

Climate control

Cooling the interior quickly

E78617

Switch the air conditioning on.

Reducing interior air humidity

E78619

HEATEDWINDOWSANDMIRRORS

Heated rearwindow

Note: The heated rearwindowoperatesonly when the ignition switch is on.

Use the heated window to defrost ordemist the rear window.

53

Climate control

E78544

Press the switch to switch the heated rearwindowon. The indicator in the switchwillcome on when the heated rear windowis on.

Press the switch again to switch theheated window off. It will switch offautomatically after a short time.

Heated exteriormirrors

Electric exterior mirrors are fitted with aheating element thatwill defrost or demistthe mirror glass. They will switch onautomaticallywhen you switch the heatedrear window on.

54

Climate control

SITTING IN THECORRECTPOSITION

E68595

WARNINGSDo not adjust the seats when thevehicle is moving.

Only when you use the seat beltproperly, can it hold you in a positionthat allows the airbag to achieve its

optimum effect.

When you use them properly, the seat,head restraint, seat belt and airbags willprovide optimum protection in the eventof a collision. We recommend that you:

• sit in an upright position with the baseof your spine as far back as possible.

• do not recline the seatbackmore than30 degrees.

• adjust the head restraint so that thetop of it is level with the top of yourhead and as far forwards as possible,remaining comfortable.

• keep sufficient distance betweenyourself and the steering wheel. Werecommend a minimum of 250millimetres (10 inches) between yourbreastbone and the airbag cover.

• hold the steeringwheelwith your armsslightly bent.

• bend your legs slightly so that you canpress the pedals fully.

• position the shoulder strap of the seatbelt over the centre of your shoulderand position the lap strap tightlyacross your hips.

Make sure that your driving position iscomfortable and that you canmaintain fullcontrol of your vehicle.

FRONTSEATS

WARNING

Do not adjust the seats when thevehicle is moving.

Moving the seats backwardsand forwards

E78678

WARNING

Rock the seat backwards andforwards after releasing the lever tomake sure that it is fully engaged in

its catch.

55

Seats

CAUTION

Do not move the front seats tooclose to the instrument panel.

Adjusting the angle of theseatback

E78679

WARNINGSRock the seatback backwards andforwards after releasing the lever tomake sure that it is fully engaged in

its catch.

If the front passenger seat has beenmoved forwards, rock the seatbackwards and forwards after

releasing the lever to make sure that it isfully engaged in its catch.

Note: On stretch cab vehicles the frontpassenger seat can be moved forwardsto allow the rear passengers to gain easieraccess.

HEADRESTRAINTS

E66539

Adjusting the head restraint

WARNING

Raise rear head restraint when therear seat is occupied by apassenger or a child restraint.

Adjust the head restraint so that the topof it is level with the top of your head.

Removing the head restraint

Press the locking buttons and remove thehead restraint.

56

Seats

REARSEATS

Folding the rear seats - 4-doorstretch cab

E78921

Folding the rear seatback -Double cab

E78922

2

1

To fold the seatback:1. Pull the release strap upwards.2. Push the seatback forwards.

To return the seatback to its uprightposition:1. Push the seatback to the upright

position.

WARNING

Make sure that the rear seatback issecure and fully engaged in itscatches

Rear seat arm rest

E83662

57

Seats

HEATEDSEATS

E78689

Note: Start the engine to use the heatedseats.

Note: The heated seats will not switchoff automatically.

The heated seats will reach theirmaximum temperature after five or sixminutes.

58

Seats

CLOCK

For detailed instructions on how to adjustthe clock. See Setting the clock onthe audio unit (page 129).

INSTRUMENT LIGHTINGDIMMER

E78453

CIGAR LIGHTER

CAUTIONSIf you use the socket when theengine is not running, the batterymay discharge.

Do not hold the cigar lighter elementpressed in.

Note: You can use the socket to power12 volt appliances that have a maximumcurrent rating of 20 Amperes. Use onlyFord accessory connectors or connectorsspecified for use with SAE standardsockets.

E72972

Press the element in to use the cigarlighter. It will pop out automatically.

For item location: SeeQuickstart (page7).

ASHTRAY

Note: The removable ashtray can beplaced in any of the front or rear cupholders.

E69119

AUXILIARYPOWERSOCKETS

E83679

59

Convenience features

CAUTION

If you use the auxiliary power socketwhen the engine is not running, thebattery may discharge.

Note: Switch the ignition on to use theauxiliary power socket.

You can use the auxiliary power socketto power 12 volt appliances that have amaximum current rating of 10 Amperes.Use only Ford accessory connectors orconnectors specified for use with SAEstandard sockets.

CUPHOLDERS

WARNINGSDo not place hot drinks in the cupholders when the vehicle is moving.

Do not place glass objects in thecup holders.

Front cup holders

E78696

Rear cup holders

E78697

GLOVEBOX

E69134

You can use the glove box as a filingcabinet.

60

Convenience features

STORAGECOMPARTMENTS

E73704 E72905

E72905

AUXILIARY INPUT (AUX IN)SOCKET

E113939

See Auxiliary input (AUX IN) socket(page 141).

61

Convenience features

GENERAL INFORMATION

General points on starting

If the battery has been disconnected thevehicle may exhibit some unusual drivingcharacteristics for approx. 8 kilometres(5 miles) after reconnecting the battery.

This is because the engine managementsystemmust realign itself with the engine.Any unusual driving characteristics duringthis period may be disregarded.

Starting the engine by towingor pushing

WARNING

To prevent damage you must notpush or tow start your vehicle. Usebooster cables and a booster

battery. See Using booster cables(page 103).

IGNITIONSWITCH

E78704

A

B CD

The ignition is off.A

The accessory circuits areenabled.

B

The ignition is on.C

The starter motor is activated.D

WARNING

Do not move the key to position Awhen the vehicle is in motion.

CAUTIONSDo not leave the key in positionB asthis will discharge the battery.

Release the key from position Dwhen the engine starts.

STEERINGWHEEL LOCK

When you remove the key from theignition switch, the steering column lockis activated as soon as you turn thesteering wheel.

The steering will be unlocked when thekey is moved to position ACC.

STARTINGADIESELENGINE

Cold or hot engine

All vehicles

Note:When the temperature is below-15ºC (5ºF), you may need to crank theengine for up to 25 seconds. If youconsistently operate the vehicle in suchtemperatures, we recommend that youhave an engine block heater fitted.

Note:Continue cranking the engine untilit starts.

Note: You can only operate the starterfor a maximum of 30 seconds at a time.

Switch the ignition on and waituntil the glow plug indicatorgoes off.

Vehicleswithmanual transmission

Note: Do not touch the acceleratorpedal.

62

Starting the engine

1. Fully depress the clutch pedal.

2. Start the engine.

Vehicleswith automatictransmission

1. Select park or neutral.

2. Fully depress the brake pedal.

3. Start the engine.

SWITCHINGOFF THEENGINE

Vehicleswith a turbocharger

CAUTION

Do not switch the engine off when itis running at high speed. If you do,the turbocharger will continue

running after the engine oil pressure hasdropped to zero. This will lead topremature turbocharger bearing wear.

Release the accelerator pedal. Wait untilthe engine has reached idle speed andthen switch it off.

63

Starting the engine

SAFETYPRECAUTIONS

WARNINGSStop refuelling after the fuel nozzlestops the second time. Additionalfuel will fill the expansion space in

the fuel tank which could lead to fueloverflowing. Fuel spillage could behazardous to other road users.

Do not use any kind of flames orheat near the fuel system. The fuelsystem is under pressure. There is

a risk of injury if the fuel system is leaking.

Filling fuel containers

WARNING

Static electricity can cause anexplosion of flammable liquid,vapour or gas in any vehicle or

trailer.

To reduce risk of serious injury or deathwhen filling containers:

• Always place container on the groundbefore filling.

• Keep the pumpnozzle in contactwiththe container while you are filling it.

• Use only approved containers forflammable liquid.

FUELQUALITY - DIESEL

WARNING

Do not mix diesel with oil, petrol orother liquids. This could cause achemical reaction.

CAUTIONSDo not add kerosene, paraffin orpetrol to diesel. This could causedamage to the fuel system.

CAUTIONSUse diesel that meets thespecification defined by EN590, orthe relevant national specification.

Note:We recommend that you use onlyhigh quality fuel.

Note: The use of additives or otherengine treatments not approved by Fordis not recommended.

Note:We do not recommend theprolonged use of additives intended toprevent fuel waxing.

Long-termstorage

Most diesel fuels contain bio-diesel, it isrecommended to fill the tank with purelymineral diesel (where available) or add ananti-oxidant prior to long-term storage ofyour vehicle exceeding twomonths. Yourdealer can help you with a suitableanti-oxidant.

CATALYTICCONVERTER

WARNING

Do not park or idle your vehicle overdry leaves, dry grass or othercombustiblematerials. The exhaust

will radiate a considerable amount of heatduring use, and after you have switchedthe engine off. This is a potential firehazard.

Drivingwith a catalyticconverter

CAUTIONSAvoid running out of fuel.

Do not crank the engine for longperiods.

64

Fuel and refuelling

CAUTIONSDo not run the engine when a sparkplug lead is disconnected.

Do not push-start or tow-start yourvehicle. Use booster cables. SeeUsingboostercables (page 103).

Do not switch the ignition off whendriving.

FUEL FILLER FLAP

E835861

2

3

E78711

Note:When the filler cap is removed, ahissing noisemay be heard. This is normaland should be disregarded.

REFUELLING

CAUTION

Do not attempt to start the engine ifyou have filled the fuel tank with theincorrect fuel. This could damage the

engine. Have the system checked by aproperly trained technician immediately.

TECHNICALSPECIFICATIONS

Fuel consumption figures

CO2emis-sionsCombinedExtra-urbanUrban

Variant

g/kml/100 km(mpg)

l/100 km(mpg)

l/100 km(mpg)

2278.3 (34)7.1 (39.8)10.3 (27.4)Vehicles with a 2.5LDuratorq-TDCi engine - 2-wheel drive

2448.9 (31.7)7.8 (36.2)10.9 (25.9)Vehicles with a 2.5LDuratorq-TDCi engine - 4-wheel drive

65

Fuel and refuelling

CO2emis-sionsCombinedExtra-urbanUrban

Variant

g/kml/100 km(mpg)

l/100 km(mpg)

l/100 km(mpg)

2609.5 (29.7)8.2(34.5)11.7 (24.1)

Vehicles with a 3.0LDuratorq-TDCi engine - 4-wheel drive (manual trans-mission)

27110.2 (27.7)8.9 (31.7)12.6 (22.4)

Vehicles with a 3.0LDuratorq-TDCi engine - 4-wheel drive (automatictransmission)

66

Fuel and refuelling

MANUAL TRANSMISSION

CAUTIONSDo not engage reverse gear whenthe vehicle is moving. This couldcause damage to the transmission.

Do not pull or push the gear leversideways too hard when you arechanging from 5th gear to 4th gear.

You could select 2nd gear unintentionallyand this could cause damage to thetransmission.

Note: Fully depress the clutch pedal andwait for three seconds before you selectreverse gear.

E68982

ALL-WHEELDRIVE (AWD)

Vehicleswithmanualtransmission

E78718

WARNING

Donot leave the selector lever in theneutral (N) positionwhen the vehicleis parked.

Note:The four-wheel drive indicator lampwill come on when the selector lever is inthe 4H or 4L position. SeeWarninglamps and indicators (page 44).

Two-wheel drive, high range (2H)

E78724

Switch off the remote free-wheel (RFW)lock mechanism when driving intwo-wheel drive.

67

Transmission

Note:Driving in two-wheel drive2Hwiththe RFW lock activated will result ingreater tyre resistance, increased fuelconsumption and unnecessary noise.

Use for all normal road driving and also foroff-road driving across dry, level terrain.

Four-wheel drive, high range (4H)

CAUTIONSDo not use four-wheel drive 4H fornormal road driving.

Do not exceed 100 km/h (62 mph).

Use for off-road driving.

Four-wheel drive, low range (4L)

CAUTIONSDo not use four-wheel drive 4L fornormal road driving.

Do not exceed 40 km/h (25 mph).

Use formoreextremeoff-roadconditions,such as steep ascents and descents.

Also use when low speed manoeuvringis necessary, such as reversing a traileror negotiating a boulder-strewn river bed,or when moving off while heavily loadedor towing. This will prevent prolongedslipping of the clutch.

Neutral (N)

Use for shifting between ranges.

Changing range

Depress the clutch pedal and shift theselector lever to the relevant position.

Shifting between (2H) and (4H)

CAUTION

Do not shift the selector leverbetween 2H and 4H with theremote free-wheel lock deactivated

and the vehiclemoving. This can damagethe drive assembly.

This can be donewith the vehiclemovingwhen the remote free-wheel (RFW) lockindicator lamp is on. SeeWarninglamps and indicators (page 44).

Shifting between (4H) and (4L)

CAUTION

Do not shift the selector leverbetween4H and4Lwith the vehiclemoving. This can damage the drive

assembly.

1. Stop the vehicle when it is safe to doso.

2. Shift the selector lever from4H to4Lor from 4L to 4H.

Shifting between (4H) and (2H)

This can be donewith the vehiclemoving.

68

Transmission

Vehicleswith automatictransmission

E92474

CAUTION

Do not turn the transfer shift switchbetween4H and4Lwith the vehiclemoving. This can damage the drive

assembly.

Two-wheel drive, high range (2H)

Use for all normal road driving and also foroff-road driving across dry, level terrain.

Four-wheel drive, high range (4H)

CAUTIONSDo not use four-wheel drive 4H fornormal road driving.

Do not exceed 100 km/h (62 mph).

Use for off-road driving.

Four-wheel drive, low range (4L)

CAUTIONSDo not use four-wheel drive 4L fornormal road driving.

Do not exceed 40 km/h (25 mph).

Note: The four-wheel drive low range4Lindicator lamp will come on when thetransfer shift switch is in the 4L position.SeeWarning lamps and indicators(page 44).

Use formoreextremeoff-roadconditions,such as steep ascents and descents.

Also use when low speed manoeuvringis necessary, such as reversing a traileror negotiating a boulder-strewn river bed,or when moving off while heavily loadedor towing.

Shifting between (2H) and (4H)

This can be donewith the vehiclemoving.

Shifting between (4H) and (4L)

CAUTION

Do not turn the transfer shift switchbetween4H and4Lwith the vehiclemoving. This can damage the drive

assembly.

1. Stop the vehicle when it is safe to doso.

2. Move the transmission selector leverto the neutral (N) position.

3. Turn the transfer shift switch from4Hto 4L or from 4L to 4H.

Shifting between (4H) and (2H)

This can be donewith the vehiclemoving.

69

Transmission

AUTOMATICTRANSMISSION

Selector lever positions

E92458

ParkP

ReverseR

NeutralN

DriveD

3rd Gear3

2nd Gear2

1st Gear1

WARNING

Apply the brakes beforemoving theselector lever and keep themapplied until you are ready to move

off.

Note: A cold engine has a higher idlespeed. This will increase the tendency foryour vehicle to creep when you haveselected a drive gear.

Press the button on the selector lever toselect reverse and park.

The selector lever position will be shownin the information display.

Park

WARNINGSSelect park only when your vehicleis stationary.

Apply the parking brake and selectpark before leaving your vehicle.Make sure that the selector lever is

latched in position.

Note:An audiblewarningwill sound if youopen the drivers door and you have notselected park.

In this position, power is not transmittedto the drive wheels and the transmissionis locked. You can start the engine withthe selector lever in this position.

Reverse

WARNING

Select reverse only when yourvehicle is stationary and the engineis at idle speed.

Neutral

In this position, power is not transmittedto the drive wheels but the transmissionis not locked. You can start the enginewith the selector lever in this position.

Drive

Select drive to shift automatically throughthe forward gears.

70

Transmission

3rdGear

Select 3, the transmission willautomatically shift between 3rd, 2nd and1st gears only.

2ndGear

Select 2, the transmission willautomatically shift between 2nd and 1stgears only.

1st Gear

Select 1, the transmission will select 1stgear only.

Hints on drivingwith anautomatic transmission

Moving off

1. Release the parking brake.

2. Release the brake pedal and pressthe accelerator pedal.

Stopping

1. Release the accelerator pedal andpress the brake pedal.

2. Apply the parking brake.

Kickdown

Press the accelerator pedal fully with theselector lever in the drive position to selectthe next highest gear for optimumperformance. Release the acceleratorpedal when you no longer requirekickdown.

Overdrive

Note: The transmission is normally inoverdrive when drive is selected.

E92459

When you are travelling in slow movingtraffic or climbing steep gradients theremay be a tendency for the transmissionto continually shift between 5th and 4thgears. If this condition should arise switchthe overdrive function off.

Note:When the overdrive function hasbeen switchedoffO/DOFFwill be shownin the information display.

Note: The transmission will only selectbetween 1st, 2nd 3rd and 4th gears if theoverdrive function has been switched off.

Drivemodes

The transmission will select theappropriate gear for optimumperformance based on ambienttemperature, road gradient, vehicle loadand driver input.

71

Transmission

PRINCIPLEOFOPERATION

Disc brakes

Wet brake discs result in reduced brakingefficiency. Dab the brake pedal whendriving froma carwash to remove the filmof water.

ABS

WARNING

The ABS does not relieve you ofyour responsibility to drive with duecare and attention.

TheABShelps you tomaintain full steeringand directional stability when you brakeheavily in an emergency, by preventingthe road wheels from locking.

HINTSONDRIVINGWITHABS

When the ABS is operating, the brakepedal will pulse. This is normal. Maintainpressure on the brake pedal.

The ABS will not eliminate the dangersinherent when:• you drive too close to the vehicle in

front of you.• the vehicle is aquaplaning.

• you take corners too fast.

• the road surface is poor.

PARKINGBRAKE

Applying the parking brake

E78772

WARNING

Make sure that the parking brake isapplied before you release the lever.

Note:Do not turn the parking brake leverwhen you apply the parking brake.

1. Press the brake pedal firmly.2. Pull the parking brake lever upwards

to its fullest extent.

Parking on a hill

If you have to park facing uphill, select firstgear and turn the front wheels away fromthe kerb. If you have to park facingdownhill, select reverse gear and turn thefront wheels towards the kerb.

Releasing the parking brake

1. Press the brake pedal firmly.2. Pull the parking brake lever upwards

slightly, turn the lever anti-clockwiseand push it downwards.

72

Brakes

PRINCIPLEOFOPERATION

WARNING

The parking aid does not relieve youof your responsibility to drive withdue care and attention.

CAUTIONSThe sensors may not detect objectsin heavy rain or other conditions thatcause disruptive reflections.

The sensors may not detect objectswith surfaces that absorb ultrasonicwaves.

The sensors may not detect objectsthat are close to the vehicle(approximately 30 centimetres (12

inches) to the rear and above or belowthe sensors).

If you use a high pressure spray towash your vehicle, only spray thesensors briefly from a distance not

less than 20 centimetres (8 inches).

The parking aid may detect anaftermarket tow bar. The parking aidwill only indicate the distance

between the bumper and the obstacle,not the distancebetween the towbar andthe obstacle.

Vehicles fitted with a trailer towmodule not approved by usmay notcorrectly detect obstacles.

The parking aid does not detectobstacles moving away from thevehicle. They will only be detected

shortly after they start to move towardsthe vehicle again.

Note: The parking aid may emit falsetones if it detects a signal using the samefrequency as the sensors or if the vehicleis fully laden.

Note: Keep the sensors free from dirt,ice and snow. Do not clean with sharpobjects.

USINGTHEPARKINGAID

E83658

150 cm

150 cm

The parking aid is automatically activatedwhen you select reverse gear with theignition switched on.

You will hear an intermittent tone at adistance of approximately 150centimetres (59 inches) between theobstacle and rear bumper and 50centimetres (20 inches) to the side.Decreasing the distance accelerates theintermittent tone. A continuous tone willstart at a distance of less than 30centimetres (12 inches) to the rearbumper.

Note: If a high pitch tone is heard forthree seconds, this indicates amalfunction. The system will be disabled.Have the system checked by a properlytrained technician.

73

Parking aid

Switching the parking aid onand off

The parking aid is per default off. Toswitch the parking aid on, press the switchin the instrument panel or select reversegear. For item location: SeeQuickstart(page 7).

The light in the switch illuminates whenthe parking aid is activated.

To turn it off, press the switch again ordisengage reverse gear.

74

Parking aid

GENERAL INFORMATION

WARNINGSUse load securing straps to anapproved standard, e.g. DIN.

Make sure that you secure all looseitems properly.

Place luggage and other loads aslow and as far forward as possiblewithin the luggage or loadspace.

Do not drive with the tailgate or reardoor open. Exhaust fumes mayenter the vehicle.

Do not exceed the maximum frontand rear axle loads for your vehicle.SeeVehicle identification (page

112).

CAUTIONSDonot allow items to contact the rearwindows.

Do not use any abrasive materials toclean the interior of the rearwindows.

Do not install stickers or labels to theinterior of the rear windows.

REARLOADSPACEHATCHES

WARNING

Do not place heavy weights directlyon the tailgate.

CAUTION

Do not lower the tailgate completelyif a tow ball is fitted.

1

2

3

E78776

Raise the tailgate slightly.1

Turn the support cableanti-clockwise.

2

Release the securing clampanddisconnect the support cable.

3

LOADRETAININGFIXTURES

Rope hooks

CAUTION

The maximum load per rope hook isstampedon or near the hook, do notexceed this load.

75

Load carrying

E78777

Note: The number of rope hooks mayvary depending on your vehicle model.

Load rest

WARNING

A loaded load rest alters thevehicle's centre of gravity andaerodynamics. Take care when

cornering, driving in crosswinds and athigh speeds.

CAUTION

Do not exceed the permissible grossweight.

E78778

Note: Secure luggage or cargo placedon the load rest with the load reststoppers.

ROOFRACKSANDLOADCARRIERS

Roof rack

WARNING

If you use a roof rack, the fuelconsumption of your vehicle will behigher and you may experience

different driving characteristics.

CAUTION

Do not exceed the maximumpermissible roof rail load of 75kilograms (165 pounds), including the

roof rack.

Check the security of the roof rack loadas follows:

• before starting

• after driving 50 kilometres (30 miles)

• at 1 000 kilometres (600 miles)intervals.

76

Load carrying

E92544

A B C

Roof railA

Sports barB

Box railC

CAUTIONSDo not sit or stand on items B or C.

Do not use item C to secure loads.

77

Load carrying

TOWINGATRAILER

WARNING

Do not exceed themaximumgrosstrain weight stated on the vehicleidentification plate. See Vehicle

identification plate (page 112).

CAUTION

Do not exceed the maximumpermissible nose weight, i.e. verticalweight on the tow ball, of 75

kilogrammes (165 pounds) for 2-wheeldrive vehicles, or 125 kilogrammes (276pounds) for 4-wheel drive vehicles.

Place loads as low and central to theaxle(s) of the trailer as possible. If you aretowing with an unladen vehicle, the loadin the trailer should be placed toward thenose, within the maximum nose load, asthis gives the best stability.

The stability of the vehicle to trailercombination is very much dependant onthe quality of the trailer.

Themaximumvehicle and trailer payloadsrepresent technically binding values forgradients up to 12% and at an altitude of1 000metres (3 281 feet) above sea level.In high altitude regions, thinneratmosphere can reduce performance sothe following restrictions will apply:

In high altitude regions above 1 000metres (3 281 feet), the stipulatedmaximum permitted gross train weightmust be reduced by 10% for everyadditional 1 000 metres (3 281 feet).

Steep gradients

WARNING

The overrun brake on a trailer is notcontrolled by the anti-lock brakingsystem.

Change down a gear before you reach asteep downhill gradient.

Technical specifications

Trailer capacities

Trailernoseweightkg (lbs)

With trailer brakekg (lbs)

Without trailerbrake kg (lbs)Variant

75 (165.3)1600 (3527.4)750 (1653.5)Single cab 2-wheeldrive

125 (275.6)3000 (6613.9)750 (1653.5)Single cab 4-wheeldrive

75 (165.3)1600 (3527.4)750 (1653.5)4-door stretch cab2-wheel drive

125 (275.6)3000 (6613.9)750 (1653.5)4-door stretch cab4-wheel drive

125 (275.6)3000 (6613.9)750 (1653.5)Double cab4-wheeldrive

78

Towing

DETACHABLE TOWBALL

WARNINGSNever leave the detached tow ballarm unsecured inside the vehicle.This would increase the risk of injury

in an accident.

When not in use, always transportthe tow ball arm securely fastenedin the luggage compartment.

Take special care when fitting thetow ball arm as the safety of thevehicle and the trailer depends on

this.

A 13-pin trailer socket and the towball armseat are provided underneath the rearbumper. Turn the trailer socket downthrough 90 degrees until it engages in thecorrect position.

Unlocking the towball armmechanism

WARNINGSDo not use any tools for mountingor dismounting the tow ball arm.

Do not modify the trailer coupling.

Do not disassemble or repair thetow ball arm.

E78801

1. Remove the plug from the seat.

2. Remove the protection cap.

3. Insert the key and turn itanti-clockwise.

Inserting the towball arm

E78802

1. Remove the lock.

2. Push the lever to the left and hold it.

3. Push the lever fully forwards until thetow ball arm is unlocked.

4. Insert the tow ball arm in to the seat.

WARNINGSThe tow ball arm may only beinsertedwhencompletely unlocked.

Make sure that the tow ball arm isfully engaged in the seat.

Note: The lever must be on the outsideof the case.

79

Towing

5. Insert the lock.

6. Insert the key in the lock and turn itclockwise.

7. Remove the key.

8. Install the protection cap.

Drivingwith a trailer

E78800

WARNING

If any of the following conditionscannot be met, do not use the towbar and have it inspected by

properly trained technicians.

Before starting your journey, make surethat the tow ball arm is properly locked.Check that:

• The tow ball is correctly locked.

• The protection cap is correctly fitted.

• The tow ball arm is fully engaged in itsseat.

Removing the towball arm

E78804

1. Remove the protection cap.

2. Insert the key and turn itanti-clockwise.

3. Remove the lock.

4. Push the lever to the left and hold it.

5. Push the lever fully forwards until thetow ball arm is unlocked.

6. Remove the tow ball arm.

7. Install the protection cap.

8. Install the plug in the seat.

Drivingwithout a trailer

1. Remove the tow ball arm.2. Install the plug into its seat.

WARNING

To avoid risk of injury, never unlockthe tow ball arm with the trailerattached.

80

Towing

Maintenance

WARNING

Remove the tow ball arm andprotect the seatwith the plug beforesteam cleaning your vehicle.

Keep the system clean.

Periodically lubricate the tow ballmechanism with resin-free grease or oiland the lock with graphite.

Keep a note of the key number. In caseof loss, replacement keys are availablefrom the manufacturer by stating the4-digit key number.

81

Towing

GENERALDRIVINGPOINTS

Vehicleswith a diesel engine

If the low fuel level warning lamp comeson, refuel as soon as possible. If youcontinue driving without refuelling, theengine will start to run unevenly. Thisindicates that you are about to run out offuel. Refuel immediately.

RUNNING-IN

Tyres

WARNING

New tyres need to be run-in forapproximately 500 kilometres (300miles). During this time, you may

experience different drivingcharacteristics.

Brakes and clutch

WARNING

Avoid heavy use of the brakes andclutch if possible for the first 150kilometres (100 miles) in town and

for the first 1 500 kilometres (1 000 miles)on motorways.

Engine

CAUTION

Avoid driving too fast during the first1 500 kilometres (1 000 miles). Varyyour speed frequently and change

up through the gears early. Do not labourthe engine.

COLDWEATHERPRECAUTIONS

The functional operation of somecomponents and systems can beaffected at temperatures below -30°C(-22°F).

REDUCEDENGINEPERFORMANCE

Your vehicle can be driven briefly if theengine overheats, without damage to theengine. The engine will continue tooperate with limited power. The distanceyou can travel depends on ambienttemperature, vehicle load, and terrain.

If the needle moves to the upper limitposition, the engine is overheating. SeeGauges (page 38).

If the temperature continues to rise, thefuel supply to the engine will be reduced.The air conditioning (if fitted) will also beturned off and the engine cooling fan willoperate.

CAUTION

Continued operationwill increase theengine temperature, and cause theengine to shut down completely.

• Stop your vehicle as soon as possible.

• Immediately turn off the engine toprevent severe engine damage.

• Wait for the engine to cool down.

• Check the coolant level. SeeEnginecoolant check (page 97).

• Have the vehicle checked by anexpert immediately.

82

Driving hints

FIRSTAIDKIT

Single cab

A retaining strap behind the right-handseat can be used to secure a first aid kit.

Stretch cab

Note: The first aid kit can be secured inthe tool bin below the rear seats.

1

2

3

E79141

Raise the rear seats.1

Fold the carpet forwards.2

Remove the cover.3

Double cab

Note: The first aid kit can be secured inthe tool bin below the rear seats.

1

2

E79142

Pull the strap upwards.1

Fold the seat forwards.2

Fold the carpet forwards.3

Remove the cover.4

WARNINGTRIANGLE

Single cab

A retaining strap behind the right-handseat can be used to secure a warningtriangle.

Stretch cab

Note: The warning triangle can besecured in the tool bin below the rearseats.

83

Emergency equipment

1

2

3

E79141

Raise the rear seats.1

Fold the carpet forwards.2

Remove the cover.3

Double cab

Note: The warning triangle can besecured in the tool bin below the rearseats.

1

2

E79142

Pull the strap upwards.1

Fold the seat forwards.2

Fold the carpet forwards.3

Remove the cover.4

84

Emergency equipment

FUSEBOXLOCATIONS

Left-hand drive

E78923

Right-hand drive

E78927

Auxiliary fuse boxA

Central fuse boxB

Auxiliary fuse box

E78924

85

Fuses

Release the catches and remove thecover.

Central fuse box

E78925

Remove the trim cover.

Inclinometerandcompassfuse

Fully open the glove compartment.

E83734

WARNING

Make sure that you keep a firm gripof the glove compartment toprevent it dropping out of the

instrument panel.

Press the sides of the glove compartmenttowards the centre to release the glovecompartment stops.

CHANGINGAFUSE

WARNINGSDo not modify the electrical systemof your vehicle in any way. Haverepairs to the electrical system and

the replacement of relays andhigh currentfuses carried out by properly trainedtechnicians.

Switch the ignition and all electricalequipment off before touching orattempting to change a fuse.

CAUTION

Fit a replacement fusewith the samerating as the one you have removed.

Note: You can identify a blown fuse bya break in the filament.

Note: All fuses, except high currentfuses, are a push fit.

86

Fuses

FUSESPECIFICATIONCHART

Central fuse box

1 2 3 4

5 6 7 8 9 10 11 12

2019181716151413

21

22

E78926

Circuits protectedColourAmpereratingFuse

Cigar lighter, audio, electric exteriormirrors, auxiliary power socketyellow201

Heated seatblue152

Windscreen wipers and washersblue153

Air conditioning, ABS relayred104

Central lockingpink305

Electric windowspink306

ABS solenoidyellow207

Brake lights, hornblue158

Hazard warning flashersred109

87

Fuses

Circuits protectedColourAmpereratingFuse

Instrument cluster, reversing lamps,direction indicators, remote free-wheel(RFW) system

blue1510

Engine management systemsblue1511

Not used--12

Air conditioning magnetic clutchred1013

Heated rear windowyellow2014

Rear fog lampred1015

Right-hand headlampblue1516

Left-hand headlampblue1517

Front fog lampblue1518

Rear lamps, side lamps, number platelampred1019

Interior lamps, warning systemblue1520

Not used--21

Electric windowspink3022

88

Fuses

Auxiliary fuse box

E83464

Circuits protectedColourAmpereratingFuse

For protection of all circuits-801

Glow plug-602

Enginemanagement systems, instrument

cluster, cigar lighter1, electric windows1-403

Headlamps-604

Injectors, fuel injection system-205

ABSmotor, hazard warning lamps, brakelamps-406

Fuel warmer-307

Air conditioning, windscreenwashers andwipers-608

Air conditioning, heated rear window1or

central locking1or ABS solenoid1or electric

windows1or tail lamps or fog lamps1-609

1Some variants

89

Fuses

Inclinometerandcompassfuse

E83729

1

Circuits protectedColourAmpereratingFuse

For protection of all inclinometer andcompass circuits-21

90

Fuses

TOWINGPOINTS

Front towpoint

E78935

Rear towpoint

WARNING

On vehicles not fitted with adetachable tow ball arm do not towvehicles.

On vehicles fitted with a detachable towball arm the towball arm can also be usedfor towing vehicles. See Detachabletowball (page 79).

TOWINGTHEVEHICLEONFOURWHEELS

WARNINGSSwitch the ignition on when yourvehicle is being towed. The steeringlock will engage and the direction

indicators and brake lamps will not workif you do not.

WARNINGSThe brake servo and the powersteering pump do not operateunless the engine is running. Press

the brake pedal harder and allow forincreased stopping distances and heaviersteering.

CAUTIONSToo much tension in the tow ropecould cause damage to your vehicleor the vehicle that is towing.

Do not use a rigid tow bar on thefront towing eye.

Do not tow your vehicle faster than50 km/h (30 mph) or further than 65kilometres (40 miles).

If a speed of 50 km/h (30 mph) anda distance of 65 kilometres (40miles)is to be exceeded your vehicle must

be transported with all 4 wheels raised.See Transporting the vehicle (page92).

In the event of a mechanical failureof the transmission your vehiclemustbe transported with all 4 wheels

raised. See Transporting thevehicle(page 92).

Select neutral when your vehicle isbeing towed.

Make sure that the vehicle is intwo-wheel drive and that theautomatic hubs are released. See

All-wheel drive (AWD) (page 67).

Drive off slowly and smoothly withoutjerking the vehicle that is towing.

91

Vehicle recovery

TRANSPORTINGTHEVEHICLE

WARNING

The wheels must be chocked andthe handbrake applied beforeremoving the driveshafts.

CAUTION

Mark the driveshaft and transfer caseflanges to make sure that they canbe correctly aligned on installation.

If a speed of 50 km/h (30 mph) and adistance of 65 kilometres (40 miles) is tobe exceeded you must remove thedriveshafts.

92

Vehicle recovery

GENERAL INFORMATION

Have your vehicle serviced regularly tohelp maintain its roadworthiness andresale value. There is a large network ofFord Authorised Repairers that are thereto help you with their professionalservicing expertise. We believe that theirspecially trained technicians are bestqualified to service your vehicle properlyand expertly. They are supported by awide range of highly specialised toolsdeveloped specifically for servicing yourvehicle.

In addition to regular servicing, werecommend that you carry out thefollowing additional checks.

WARNINGSSwitch the ignition off beforetouching or attempting adjustmentof any kind.

Do not touch the electronic ignitionsystem parts after you haveswitched the ignition on orwhen the

engine is running. The system operatesat high voltage.

Keep your hands and clothing clearof the engine cooling fan. Undercertain conditions, the fan may

continue to run for several minutes afteryou have switched the engine off.

CAUTION

When carrying out maintenancechecks,make sure that filler caps arefitted securely.

Daily checks

• Exterior lamps.

• Interior lamps.

• Warning lamps and indicators.

Checkwhen refuelling

• Engine oil level. See Engine oilcheck (page 96).

• Brake fluid level. See Brake andclutch fluid check (page 98).

• Washer fluid level. SeeWasherfluidcheck (page 98).

• Tyre pressures (when cold). SeeTechnical specifications (page111).

• Tyre condition. SeeTyrecare (page110).

Monthly checks

• Engine coolant level (engine cold).See Engine coolant check (page97).

• Pipes, hoses and reservoirs for leaks.

• Power steering fluid level. SeePowersteeringfluidcheck (page97).

• Air conditioning operation.

• Parking brake operation.

• Horn operation.

• Tightness of wheel nuts. SeeTechnical specifications (page111).

93

Maintenance

OPENINGANDCLOSINGTHEBONNET

E79035

1. Pull the lever under the instrumentpanel.

E79036

2

43

2. Raise the bonnet slightly.

3. Move the catch towards the left-handside of the vehicle.

4. Open the bonnet.

E79037

5. Support it with the strut.

Closing the bonnet

Note:Make sure that the bonnet isclosed properly.

Lower the bonnet and allow it to dropfrom under its own weight for the last20 – 30 centimetres.

94

Maintenance

ENGINECOMPARTMENTOVERVIEW - 2.5LDURATORQ-TDCI (WL) DIESEL/3.0LDURATORQ-TDCI (WL) DIESEL

E78937

A B C D

JL KM I H

E F G

Auxiliary fuse box. See Changing a fuse (page 86).A

Power steering fluid reservoir. See Power steering fluid check (page97).

B

Fuel filter. See Draining the fuel filterwater trap (page 98).C

Brake and clutch fluid reservoir (right-hand drive). See Brake and clutchfluid check (page 98).

D

Vehicle identification plate. See Vehicle identification plate (page 112).E

Brake and clutch fluid reservoir (left-hand drive). See Brake and clutchfluid check (page 98).

F

Air cleaner.G

Engine coolant reservoir. See Engine coolant check (page 97).H

Coolant system cap. See Engine coolant check (page 97).I

Engine oil dipstick. See Engine oil check (page 96).J

Engine oil filler cap. See Engine oil check (page 96).K

95

Maintenance

Battery. See Vehicle battery (page 103).L

Washer fluid reservoir. SeeWasher fluid check (page 98).M

ENGINEOILCHECK

CAUTION

Do not use oil additives or otherengine treatments. Under certainconditions, they could damage the

engine.

Note: The oil consumption of newengines reaches its normal level afterapproximately 5 000 kilometres (3 000miles).

Checking the oil level

E79039

A B

MINA

MAXB

Note: Check the oil level before startingthe engine.

Note:Make sure that your vehicle is onlevel ground.

Note:Oil expandswhen it is hot. The levelmay therefore extend a few millimetresbeyond theMAXmark.

Remove the dipstick and wipe it with aclean, lint free cloth. Replace the dipstickand remove it again to check the oil level.

Make sure that the oil level is between theMIN and theMAXmarks. If it is, you donot need to top up. If it is at theMINmark, top up immediately.

Topping up the oil

E79040

WARNING

Donot remove the oil filler capwhenthe engine is running.

Remove the oil filler cap.

CAUTION

Do not top up further than theMAXmark.

Top up with oil that meets the Fordspecification. See Technicalspecifications (page 99).

Replace the oil filler cap. Turn it until youhear a click.

96

Maintenance

ENGINECOOLANTCHECK

Checking the coolant level

E79043

CAUTION

Make sure that the coolant level isbetween the FULL and the LOWmarks.

Note: Coolant expands when it is hot.The level may therefore extend beyondthe FULLmark.

Topping up the coolant

WARNING

Donot remove the coolant reservoircapwhen the engine is hot.Wait forthe engine to cool down.

Remove the cap slowly. Any pressurewill escape slowly as you remove the cap.

WARNINGSOnly add coolant when the engineis cold. If the engine is hot, wait 10minutes for the engine to cool

down.

WARNINGSDo not allow coolant to touch yourskin or eyes. If this happens, rinsethe affected areas immediately with

plenty of water and contact your doctor.

CAUTION

Do not spill coolant on any part of theengine.

Only add coolant that meets the Fordspecification. See Technicalspecifications (page 99).

POWERSTEERINGFLUIDCHECK

WARNING

Do not allow the fluid to touch yourskin or eyes. If this happens, rinsethe affected areas immediately with

plenty of water and contact your doctor.

CAUTION

Make sure that the level is betweentheMIN and theMAXmarks.

If the level is at theMINmark, top upimmediately.

Topping up

Remove the filler cap.

CAUTION

Do not top up further than theMAXmark.

Top up with fluid that meets the Fordspecification. See Technicalspecifications (page 99).

97

Maintenance

BRAKEANDCLUTCHFLUIDCHECK

WARNINGSDo not allow the fluid to touch yourskin or eyes. If this happens, rinsethe affected areas immediately with

plenty of water and contact your doctor.

If the level is at theMINmark, havethe system checked by a properlytrained technician as soon as

possible.

Note: The brake and the clutch systemsare supplied from the same reservoir.

Top up with fluid that meets the Fordspecification. See Technicalspecifications (page 99).

DRAININGTHEFUELFILTERWATER TRAP

WARNING

Do not dispose of diesel inhousehold refuse or the publicsewage system. Use your local

authorised waste disposal facilities.

Note: Only add fuel that meets the Fordspecification. See Fuel quality (page64).

3

2

E78554

1

1. Place a suitable container below thefuel filter.

2. Loosen the drain plug byapproximately 1 turn.

3. Push the priming pumpapproximately7 times.

4. Tighten the drain plug.

Start the engine and check for leaks.

Note: The water-in-fuel indicator lampwill go out after approximately 2 seconds,with the engine running.

WASHERFLUIDCHECK

The front and rear washer systems aresupplied from the same reservoir.

98

Maintenance

TECHNICALSPECIFICATIONS

Vehicle fluids

SpecificationRecommended fluidPart

WSS-M2C913-CCastrol Engine Oil*Engine oil

WSA-M2C195-AFord Power Steering FluidPower assisted steering

WSS-M97B44-DMotorcraft SuperPlus Anti-freezeCoolant

ESD-M6C57-AFord or Motorcraft SuperDOT 4 Brake FluidBrake fluid

* Providing it meets the specification defined byWSS-M2C913-C, you can also useFord Engine Oil or an alternative engine oil.

Toppinguptheoil: If you are unable to find an oil thatmeets the specification definedbyWSS-M2C913-C, you must use SAE5W-30 (preferred), SAE5W-40 or SAE10W-40 that meets the specification defined by either ACEAA5/B5 (preferred) orACEAA3/B3. Using these oils can result in longer engine cranking periods, reducedengine performance, reduced fuel economy and increased emission levels.

Castrol engine oil recommended.

E115472

Capacities

Capacity in litres(gallons)ItemVariant

MAX-markPower assisted steeringfluidAll

1.8 (0.4)Windscreenwasher systemAll

63 (13.9)Fuel tankAll - 2-wheel drive

70 (15.4)Fuel tankAll - 4-wheel drive

7 (1.5)Engine oil − with filterAll

6.8 (1.5)Engine oil − without filterAll

9.4 (2.1)Cooling system incl. heatingsystemAll

99

Maintenance

Capacity in litres(gallons)ItemVariant

8.8 (1.9)Cooling system excl.heating systemAll

100

Maintenance

CLEANINGTHEEXTERIOR

WARNING

If you use a car wash with a waxingcycle, make sure that you removethe wax from the windscreen.

CAUTIONSPrior to using a car wash facilitycheck the suitability of it for yourvehicle.

Some car wash installations usewater at high pressure. This coulddamage certain parts of your vehicle.

Remove the aerial before using anautomatic car wash.

Switch the heater blower off toprevent contamination of the freshair filter.

We recommend that you wash yourvehicle with a sponge and lukewarmwater containing a car shampoo.

Cleaning the headlamps

CAUTIONSDo not scrape the headlamp lensesor use abrasives, alcoholic solventsor chemical solvents to clean them.

Do not wipe the headlamps whenthey are dry.

Cleaning the rearwindow

CAUTION

Do not scrape the inside of the rearwindowor use abrasives or chemicalsolvents to clean it.

Use a clean, lint free cloth or a dampchamois leather to clean the inside of therear window.

Cleaning the chrome trim

CAUTION

Do not use abrasives or chemicalsolvents. Use soapy water.

Body paintwork preservation

CAUTIONSDo not polish your vehicle in strongsunshine.

Do not allow polish to touch plasticsurfaces. It could be difficult toremove.

Donot apply polish to thewindscreenor rear window. This could cause thewipers to become noisy and they

may not clear the window properly.

We recommend that you wax thepaintwork once or twice a year.

CLEANINGTHE INTERIOR

Seat belts

WARNINGSDo not use abrasives, or chemicalsolvents to clean them.

Do not allow moisture to penetratethe seat belt retractor mechanism.

Clean the seat belts with interior cleaneror water applied with a soft sponge. Letthe seat belts dry naturally, away fromartificial heat.

101

Vehicle care

Instrument cluster screens,LCD screens, radio screens

WARNING

Do not use abrasives, alcoholicsolvents or chemical solvents toclean them.

REPAIRINGMINORPAINTDAMAGE

CAUTION

Removeapparently harmless lookingsubstances from the paintworkimmediately (e.g. bird droppings, tree

resins, insect remains, tar spots, road saltand industrial fall out).

You should repair paintwork damagecaused by stones from the road or minorscratches as soon as possible. A choiceof products is available from your FordDealer. Read and follow themanufacturer’s instructions.

102

Vehicle care

BATTERYCARE

The battery requires very littlemaintenance. The fluid level is checkedregularly during the routine serviceinspections.

USINGBOOSTERCABLES

CAUTIONSConnect batterieswith only the samenominal voltage.

Always use booster cables withinsulated clamps and adequate sizecable.

Do not disconnect the battery fromthe vehicle’s electrical system.

Toconnect thebooster cables

A

B

C

D

E79135

Flat battery vehicleA

Booster battery vehicleB

Positive connection cableC

Negative connection cableD

• Position the vehicles so they do nottouch.

• Switch off the engine and anyelectrical equipment.

103

Vehicle battery

• Connect the positive (+) terminal ofthe battery plus connection with thepositive (+) terminal of the battery onthe other vehicle (cable C).

• Connect one end of the negativeconnection cable to the engine blockor the engine mount of your vehicle.Connect the other end to the othervehicle, as far away as possible fromthe battery to the engine block or theengine mount (cable D).

CAUTIONSDonotconnect to thenegative(–) terminal of the flat battery.

Make sure that the jump leads areclear of any moving parts.

To start the engine

• Run the engine of the other vehicle atmoderately high speed.

• Start your engine.

• Run both engines for a minimum of 3minutes before disconnecting theleads.

CAUTION

Do not switch on the headlampswhen disconnecting the cables. Thepeak voltage could blow the bulbs.

• Disconnect the cables in the reverseorder.

104

Vehicle battery

GENERAL INFORMATION

E79170

Set the pressure for your spare tyre to thehighest value given for your vehicle andtyre size combination.

Data about tyres, rims and tyre pressuresfor special vehicle model variants is onlygiven on the tyre pressure decal on thesevehicles.

CHANGINGAROADWHEEL

Sparewheel

CAUTION

Use only approved wheel and tyresizes. Using other sizes coulddamage the vehicle and will make

the National Type Approval invalid.

The spare wheel is located underneaththe rear of the vehicle.

E79147

E79149

1. Fully insert the jack handle into theguide hole. Turn anti-clockwise untilthe wheel rests on the ground, andthere is slack in the cable.

105

Wheels and tyres

2. Pass the bracket and cable throughthe wheel opening.

Vehicle jack

CAUTION

Use only the specified jacking points.Positioning at other points maydamage the body, steering,

suspension, engine, braking system, orfuel lines.

The jack, wheel brace, and jack handleare located in the cab.

Single cab

E79140

1. Fold the seatbacks forward.

4-door Stretch cab

1

2

3

E79141

1. Raise the rear seats.

2. Fold back the carpet.

3. Raise the cover.

E79146

45

4. Remove the bolt.

106

Wheels and tyres

5. Lift the retaining bracket up andremove the jack.

Double cab

1

2

E79142

1. Lift the release strap.

2. Lower the seatback.

3

4

E79144

3. Turn the locking valve anti-clockwiseto release the pressure.

4. Release the retaining clip and removethe jack.

Jacking points

2-wheel drive vehicles

E79151

Position the jack behind the front wheelon the chassis or behind the rear wheelon the spring.

107

Wheels and tyres

4-wheel drive vehicles

E79152

Position the jack behind the front wheelon the axle or behind the rear wheelbetween the U-bolts on the spring.

Additional jacking points

E79154

Trolley jacks (Front axle only on4-wheel drive vehicles)

1

Workshop hoists2

Axle stands3

Removing awheel

WARNINGSPark your vehicle in such a positionthat neither the traffic nor you arehindered or endangered.

Set up a warning triangle.

Make sure that the vehicle is on firm,level ground with the wheelspointing straight ahead.

Switch off the ignition and apply thehandbrake.

If your vehicle has a manualtransmission, select first or reversegear. If it has an automatic

transmission, select park.

Have the passengers leave thevehicle.

Always secure the diagonallyopposite wheel with an appropriateblock or wheel chock when

changing a wheel.

108

Wheels and tyres

WARNINGSMake sure that the arrows ondirectional tyres point in the directionof rotation when the vehicle is

moving forwards. If a spare wheel has tobe fitted with the arrows pointing in theopposite direction of rotation, have thetyre refitted in the correct direction by aproperly trained technician.

Only use the vehicle jack to changea wheel. Never work underneaththe vehiclewhen it is supported only

by the jack.

Note:Make sure that the jack is verticalto the jacking point and the base is flat onthe ground.

E70956

1. Remove the hub cover.

2. Remove the nut caps.

1 2

3

E79153

3. Assemble the jack handle.

4. Slacken the wheel nuts.

5. Jack up the vehicle until the tyre isclear of the ground.

E70960

6. Unscrew and remove the wheel nutsand take off the wheel.

Fitting awheel

WARNINGSMake sure that there is nolubrication (grease or oil) on thethreads or the interface between

wheel studs and nuts.

Have the tightening torque of thewheel nuts and the tyre pressurechecked as soon as possible.

Note: Thewheel nuts of alloywheels canalso be used for the steel spare wheel.

1. Align and fit the wheel onto the wheelstuds.Make sure that the flat washersof thewheel nuts are facing thewheel.Screw on the wheel nuts and tighten.

2. Lower the vehicle and remove thejack.

109

Wheels and tyres

E79156

1

2

65

4

3

3. Fully tighten the wheel nuts in thepattern shown.

4. Press on the hub cap firmly with theball of the hand.

5. Press on the nut caps firmly.

Stowing thewheel

CAUTION

Do not raise the spare wheel carrierwithout thewheel attached. Damagecan occur to the winch mechanism

if lowered without a wheel attached.

1. Place thewheel flat on the ground, sothe outside of the wheel faces down.Tilt the bracket, and pass it and thecable through the centre opening inthe wheel.

2. Fully insert the flat end of the wheelbrace into the guide hole and turnclockwise.

3. Stow the wheel brace, jack, and jackhandle away.

TYRECARE

E70415

To make sure the front and rear tyres ofyour vehicle wear evenly and last longer,we recommend that you swap the tyresfrom front to rear and vice versa at regularintervals of 15 000 to 20 000 km (9 000to 12 000 miles).

CAUTION

Do not scrub the sidewalls of thetyres when you are parking.

If you have to mount a kerb, do so slowlyand approach it with the wheels atright-angles to the kerb.

Examine the tyres regularly for cuts,foreign objects and uneven wear of thetread. Uneven wear could mean that thewheel alignment is outside specification.

USINGWINTER TYRES

CAUTION

Make sure that you use the correctwheel nuts for the type of wheel thewinter tyres are fitted to.

If winter tyres are used, make sure thatthe tyre pressures are correct. SeeTechnical specifications (page 111).

110

Wheels and tyres

USINGSNOWCHAINS

WARNINGSDo not exceed 50 km/h (30 mph).

Do not use snow chains onsnow-free roads.

CAUTIONSDo not fit snow chains to 245/70R 16tyres

If your vehicle is fitted with wheeltrims, remove them before fittingsnow chains.

Note: The ABS will continue to operatenormally.

Note: Tighten the snow chains after 1 km(0.5 miles).

Only use small link snow chains.

Only use snowchains on the frontwheels.

On 4-wheel drive vehicles, inflate the reartyres to the maximum pressurepermissible. See Technicalspecifications (page 111).

TECHNICALSPECIFICATIONS

Tyre pressures (cold tyres)

bar (lbf/in)Max.axle loadkg(lbs)Tyre sizeVariant

rearfrontrearfront

2.1 (30)/3.8 (54)2.2 (32)1860

(4100)1170 (2579)215/70R 15C2-wheeldrive

2.1 (30)/2.9 (42)2.1 (30)1850

(4078)1430(3152)235/75R 154-wheel

drive

2.1 (30)/2.7 (39)2.1 (30)1850

(4078)1430(3152)245/70R 164-wheel

drive

2.1 (30)/2.7 (39)2.1 (30)1850

(4078)1430(3152)255/60R 184-wheel

drive

111

Wheels and tyres

VEHICLE IDENTIFICATIONPLATE

E79172

The vehicle identification plate is locatedin the engine compartment.

VEHICLE IDENTIFICATIONNUMBER (VIN)

The vehicle identification number isstamped onto the plastic tag on theleft-hand side of the instrument panel.

112

Vehicle identification

TECHNICALSPECIFICATIONS

Vehicle dimensions

Single cab

E79187

113

Technical specifications

Dimension inmm(inches)

Dimension descriptionItem

5090 (200.4)Maximum length (2-wheel drive)A

5170 (203.5)Maximum length (4-wheel drive)A

1715 (67.5)Overall width - excl. exteriormirrors (2-wheel drive)B

1805 (71.1)Overall width - excl. exteriormirrors (4-wheel drive)B

1620 (63.8)Overall height (2-wheel drive)C

1745 (68.7)Overall height (4-wheel drive)C

2985 (117.5)Wheelbase (2-wheel drive)D

3000 (118.1)Wheelbase (4-wheel drive)D

1445 (56.9)Track - Front (2-wheel drive)E

1445 (56.9)Track - Front (4-wheel drive)E

1450 (57.1)Track - rear (2-wheel drive)E

1440 (56.7)Track - rear (4-wheel drive)E

114

Technical specifications

4-door stretch cab

E79188

Dimension inmm(inches)

Dimension descriptionItem

5160 (203.1)Maximum length (2-wheel drive)A

5180 (203.9)Maximum length (4-wheel drive)A

1715 (67.5)Overall width - excl. exteriormirrors (2-wheel drive)B

115

Technical specifications

Dimension inmm(inches)

Dimension descriptionItem

1805 (71.1)Overall width - excl. exteriormirrors (4-wheel drive)B

1620 (63.8)Overall height (2-wheel drive)C

1745 - 1750 (68.7 -68.9)1Overall height (4-wheel drive)C

2985 (117.5)Wheelbase (2-wheel drive)D

3000 (118.1)Wheelbase (4-wheel drive)D

1445 (56.9)Track - Front (2-wheel drive)E

1445 (56.9)Track - Front (4-wheel drive)E

1450 (57.1)Track - rear (2-wheel drive)E

1440 - 1470 (56.7 -57.9)1Track - rear (4-wheel drive)E

1Depending on tyre size

116

Technical specifications

Double cab

E79189

Dimension inmm(inches)

Dimension descriptionItem

5170 (203.5)Maximum length (2-wheel drive)A

5170 (203.5)Maximum length (4-wheel drive)A

1715 (67.5)Overall width - excl. exteriormirrors (2-wheel drive)B

117

Technical specifications

Dimension inmm(inches)

Dimension descriptionItem

1805 (71.1)Overall width - excl. exteriormirrors (4-wheel drive)B

1630 (64.2)Overall height (2-wheel drive)C

1755 - 1760 (69.1 - 69.3)1Overall height (4-wheel drive)C

2985 (117.5)Wheelbase (2-wheel drive)D

3000 (118.1)Wheelbase (4-wheel drive)D

1445 (56.9)Track - Front (2-wheel drive)E

1445 - 1475 (56.9 - 58.1)1Track - Front (4-wheel drive)E

1450 (57.1)Track - Rear (2-wheel drive)E

1440 - 1470 (56.7 -57.9)1Track - Rear (4-wheel drive)E

1Depending on tyre size

118

Technical specifications

Towing equipment dimensions

E79190

Dimension inmm(inches)

Dimension descriptionItem

97.5 ± 5 (3.8 ± 0.2)Attachment point - centre of tow ball (2-wheeldrive)

A

188 ± 5 (7.4 ± 0.2)Attachment point - centre of tow ball (4-wheeldrive)

A

541 (21.3)Centre of tow ball - side member (2-wheel drive)B

541 (21.3)Centre of tow ball - side member (4-wheel drive)B

1082 (42.6)Outside of side member (2-wheel drive)C

1082 (42.6)Outside of side member (4-wheel drive)C

325 ± 5 (12.8 ± 0.2)Centre of tow ball - centre 1. attachment point(2-wheel drive)

D

307 ± 5 (12.1 ± 0.2)Centre of tow ball - centre 1. attachment point(4-wheel drive)

D

119

Technical specifications

Dimension inmm(inches)

Dimension descriptionItem

425 ± 5 (16.7 ± 0.2)Centre of tow ball - centre 2. attachment point(2-wheel drive)

E

407 ± 5 (16 ± 0.2)Centre of tow ball - centre 2. attachment point(4-wheel drive)

E

560 ± 5 (22 ± 0.2)Centre of tow ball - centre 3. attachment point(2-wheel drive)

F

542 ± 5 (21.4 ± 0.2)Centre of tow ball - centre 3. attachment point(4-wheel drive)

F

Vehicleweight

Permissible grossweight kg (lbs)Payload kg (lbs)Kerbweight kg

(lbs)Variant

2800 (6173)1080 (2381)1645 (3627)Single cab 2-wheeldrive

3010 (6636)1135 (2502)1800 (3968)Single cab 4-wheeldrive

2900 (6393)926 (2041)1749 (3856)4-door stretch cab2-wheel drive

3070 (6768)990 (2183)1855 (4096)4-door stretch cab4-wheel drive

2855 (6294)815 (1797)1740 (3836)

Double cab2-wheeldrive (Vehicles witha 2.5L Duratorq-TDCi engine)

2985 (6581)835 (1841)1850 (4079)

Double cab4-wheeldrive (Vehicles witha 2.5L Duratorq-TDCi engine)

2985 (6581)835 (1841)1850 (4079)

Double cab4-wheeldrive (Vehicles witha 3.0L Duratorq-TDCi engine -manual transmis-sion)

120

Technical specifications

Permissible grossweight kg (lbs)Payload kg (lbs)Kerbweight kg

(lbs)Variant

2995 (6603)835 (1841)1860 (4101)

Double cab4-wheeldrive (Vehicles witha 3.0L Duratorq-TDCi engine - auto-matic transmission)

121

Technical specifications

IMPORTANTAUDIOINFORMATION

WARNINGSDue to technical incompatibility,some recordable (CD-R) andrewritable (CD-RW) discs may not

function correctly.

These CD radio units will playcompact discs that conform to theInternational Red Book standard

audio specification. Copy protected CDsfromsomemanufacturersdonot conformto this standard and playback cannot beguaranteed.

Dual format, dual sided discs (DVDPlus, CD-DVD format), adopted bythe music industry, are thicker than

normal CDs and consequently playbackcannot be guaranteed. Jamming of theCD mechanism could occur. Irregularshaped CDs and CDs with a scratchprotection film or self adhesive labelsattached should not be used. Warrantyclaims, where this type of disc is found tobe inside an audio unit returned for repair,will not be accepted.

All CD units are designed to playcommercially pressed 12 cm audiocompact discs. The 6-disc in dash

unit will also play 8 cm discs only with an8 cm CD adaptor fitted. Do not attemptto use 8cm compact discs in the singleCD unit, with or without an adaptor.

The audio unit may be damaged ifunsuitable items like credit cards orcoins are pushed inside the CD

aperture.

Audio unit labels

E66256

E66257

Disc labels

AudioCD

E66254

MP3

E66255

122

Audio introduction

AUDIOUNITOVERVIEW

Single CDplayer

E83496

123

Audio unit overview

6-disc in dashCDplayer

E83479

124

Audio unit overview

Button function overview

E83480

Q P LNO KR

DC

H

I

J

A B F GE

M

U

T

S

Clock button.A

Load button.B

Waveband selector buttons.C

Display.D

CD play button.E

CD slot.F

CD eject button.G

Channel preset button 4 / Fast forward.H

Channel preset button 5 / Reverse.I

Channel preset button 6 / Random.J

125

Audio unit overview

Audio control dial / Manual tuning.K

Alternative frequency button.L

Traffic announcement button.M

Minute set button / Seek tuning / Track up.N

Hour set button / Seek tuning / Track down.O

Programme type button.P

Auto memory button / Display.Q

Power/volume dial.R

Channel preset button 3 / Repeat.S

Channel preset button 2 / Disc down.T

Channel preset button 1 / Disc up.U

126

Audio unit overview

SECURITYCODE

To deter theft of your vehicle's audio unit,it has an integrated anti theft system. Thesystem is designed to accept a codenumber that makes the unit inoperable ifit is stolen. This system will be activated ifthe power source is ever disconnectedfrom or in any way interrupted to theaudio unit. When the system is activated,the audio system will not operate whenreconnected to a power supply, and'CODE' will flash on the display until thecorrect code number is input. If the antitheft system is activated, reset the unit.

CAUTION

Readandunderstand all code settingprocedures before attempting toinput your personal code number.

The personal code number is only shownon the audio unit display while it is beingset. Once it is input and stored by the unit,it is never again displayed. For that reason,be very careful to immediately record yourpersonal code number, and never let anunauthorised person set a code.

Note:Although the audio unit is operablewithout the code number being set, werecommend that you set your personalcode number.

LOSTSECURITYCODE

If you lose the Keycode, contact yourdealer and supply details of your audiounit along with some proof of identity.Your Dealer will then obtain the correctcode from Ford Motor Company.

ENTERINGASECURITYCODE

Setting procedure

1. Begin with the audio unit off and theignition switch in the ACC position.

2. Press the AUTO-M button and thechannel preset button 6simultaneously for about 2 secondsuntil 'CODE' is displayed.

3. Again press the AUTO-M button andthe channel preset button 6simultaneously while 'CODE' isdisplayed (within 10 seconds). Thedisplay bars '----' will appear.

4. While the bars are displayed, inputyour personal code number bypressing channel preset buttons 1, 2,3, and 4. Press 1 for the first digit, 2 forthe second, 3 for the third, and 4 forthe last digit. For example, if yournumber is 4213, press 1 five times, 2three times, 3 twice, and 4 four times.If the display goes off while inputting,begin from Step 1.

5. While the code number is displayed,press the AUTO-M button and thechannel preset button 6simultaneously for about 2 seconds.The unit will beep and 'CODE' willbegin to flash. After about 5 seconds,'CODE' will disappear. This indicatesthe system is set.

Note:We recommend that your codenumber be associated with somethingeasy to remember. You should also file acopy of the code numbers with yourvehicle documents.

127

Audio systemsecurity

Note: If 'ERR' (error) appears on thedisplay, repeat the procedure from Step4. If 'ERR' (error) is displayed 3 timesconsecutively, code input cannot becompleted. If this happens, turn theignition switch to the off position and startthe procedure from the beginning.

Cancelling the code number

1. Begin with the audio unit off and theignition switch in the ACC position.

2. Press the AUTO-M button and thechannel preset button 6simultaneously for about 2 secondsuntil 'CODE' is displayed.

3. Again press the AUTO-M button andthe channel preset button 6simultaneously while 'CODE' isdisplayed (within 10 seconds). Thedisplay bars '----' will appear.

4. While the bars are displayed, input thecurrent code number as described insetting procedure Step 4. (4213, forexample).

5. While the code number is displayed,press the AUTO-M button and thechannel preset button 6simultaneously for about 2 seconds.The unit will beep and 'CODE' will bedisplayed.

6. After 5 seconds, 'CODE' willdisappear. This indicates the codenumber is cancelled.

Note: If 'ERR' (error) appears on thedisplay, repeat the procedure from Step4. If 'ERR' (error) is displayed 3 timesconsecutively, code input cannot becompleted. If this happens, turn theignition switch to the off position and startthe procedure from the beginning.

Changing the code number

To change the code number, first cancelthe number. Then set the new numberby following the setting procedures.

Systemactivation

When the power supply is disconnectedor interrupted, the anti theft system isactivated and the unit is renderedinoperative. In this condition, when poweris again supplied, 'CODE'will be displayedand flash unless the correct code numberis input.

To deactivate the anti theft system andreset the audio unit, input your personalcode number.

1. Press the AUTO-M button and thechannel preset button 6simultaneously for about 2 secondsuntil bars are displayed.

2. While the bars are displayed, input thecode number as described in thesetting procedure.

3. Press the AUTO-M button and thechannel preset button 6 for about 2seconds. The unit will beep and'CODE' will be displayed for 5seconds, then disappear to indicatethat the system is operable. If 'ERR'(error) appears, begin from Step 1.

INCORRECTSECURITYCODE

Once you have set a security code, thereare a limited number of attempts allowedto enter it following activation. Only threeattempts are allowed before the unit willbe permanently locked.

CAUTIONSThree consecutive errorswill activatethe anti theft system, and the audiounit will become completely

inoperable. 'ERR' (error) will flash. Whenthis happens, youmust contact your localFord dealer for help.

Do not allow an unauthorised personto attempt to input a code number.

128

Audio systemsecurity

SETTINGTHECLOCKONTHEAUDIOUNIT

Changing the time

The clock can be set at any time whenthe ignition switch is in the ACC or ONposition.

• Press the CLOCK button for abouttwo seconds until a beep is heard. Theclock's current time will flash.

• To advance the hours, press theHOUR SET button. To advance theminutes, press the MINUTE SETbutton while the time is flashing.

• Press the CLOCK button to confirmand set.

12/24 hour format

To switch between a 12 and24 hour clockdisplay, press the display switch buttons(AF, AUTO MEMORY) while the time isflashing.

Exact hour adjustment

You can set the time to the beginning ofan hour using this feature.

• Press the CLOCK button for abouttwo seconds until a beep is heard. Theclock's current time will flash.

• Press the CLOCK button again andthe time will be adjusted as follows:

Example

• current set time between 12:01 and12:29 will change to 12:00 exactly

• current set time between 12:30 and12:59 will change to 1:00 exactly.

Note: If the power supply to the unit isinterrupted (if the fuse blows or thevehicle's battery is disconnected), theclock will need to be reset.

129

Audio unit clock and date displays

ON/OFFCONTROL

Turn the ignition switch to the ACC or ONposition.

Press the POWER/VOLUME dial to turnthe audio system on. Press thePOWER/VOLUME dial again to turn theaudio system off.

CAUTION

To prevent the battery from beingdischarged, do not leave the audiosystem on for a long period of time

when the engine is not running.

VOLUMECONTROL

Use this control to raise or lower thevolumeof the current audio source at anytime.When youmake an adjustment, thedisplay indicates the selected volumelevel.

STATIONTUNINGCONTROL

Seek tuning

Select a waveband and briefly press oneof the seek tuning arrowbuttons. The unitwill stop at the first station it finds in thedirection you have chosen.

Note: If you continue to press and holdthe button, the frequency will continuechanging without stopping.

Manual tuning

Turning themanual tuning dial will changethe frequency higher and lower. Thedisplay shows the frequency selected.

STATIONPRESETBUTTONS

This feature allows you to store yourfavourite stations so that they can berecalled by selecting the appropriatewaveband andpressing oneof the presetbuttons.

• Select a waveband.

• Tune to the station required.

• Press and hold one of the presetbuttons until a beep is heard. Thepreset channel number and stationfrequency or name will be displayed.The station is nowheld in thememory.

This can be repeated on eachwavebandand for each preset button.

AUDIOMENUCONTROL

Press the audio control dial to select thefunction. The selected function will beindicated.

Turn the audio control dial to adjust theselected functions as follows:

Dial rightDial leftDisplay

Selectmode

Selectmode

ALC OFF*

Increasebass

Decreasebass

BASS

Increasetreble

Decreasetreble

TREB

Shift thesound tothe rear

Shift thesound tothe front

FADE

Shift thesound tothe right

Shift thesound tothe left

BAL

130

Audio unit operation

Dial rightDial leftDisplay

ONOFFBEEP ON*

*Depending on the mode selected, thisdisplay will change.

Note: About 5 seconds after selectingany mode, the volume function will beautomatically selected. To reset bass,treble, fade, and balance, press the audiocontrol dial for 2 seconds. The unit willbeep and 'CLEAR' will be displayed.

Beep setting

The beep sound when operating theaudio system can be turned on or off.

WAVEBANDBUTTON

These buttons allow you to switchbetween the AM and FM wavebands.

Press the AM button to select MWor LW,and FM1 or FM2 to select FM. The displayindicates the selectionmade. If FM stereois being received, 'ST' will be displayed.

Note: If the FM signal becomes weak,reception automatically changes fromstereo to mono to reduce noise, and the'ST' indicator will disappear.

This control can be used to return to radioreception when you have been listeningto another source such as CD.

AUTOSTORECONTROL

Automatic memory tuning can be usedto store the stations with the strongestsignals available, either from the AM orFM wavebands. This is especially usefulwhen driving in an area where the localstations are not known.

• Press and hold the AUTO MEMORYbutton for about two seconds until abeep is heard.

• The systemwill automatically scan andtemporarily store up to six stationswith the strongest frequencies in eachselected band in that area.

• After scanning is completed, thestation with the strongest frequencywill be tuned and its frequencydisplayed. Press and release theAUTO MEMORY button to recallstations from the auto-stored stations.One stored station will be selectedeach time; its frequency and channelnumber will be displayed.

Note: If no stations can be tuned afterthe scanning process, 'A' will bedisplayed.

TRAFFIC INFORMATIONCONTROL

Before you can receive trafficannouncements, you must press the TAbutton. If the traffic announcement (TA)button is pressedwhile the radio is on, theunit switches to TA mode and 'TP' isdisplayed.

Once in TA mode, only road trafficannouncements are searched. If acurrently tuned radio station is notbroadcasting a traffic announcementwhen the traffic announcement button ispressed, the radio will automatically seekone in another network. If no applicablestation is found, 'Nothing' will be displayedand the system will return to thepreviously tuned station.

131

Audio unit operation

When in TA mode or a mode other thanthe radio, and the traffic announcementbutton is pressed, the system switchesto TA stand-by mode and 'TA' and 'TP'will be displayed. If the currently tunedradio station is not broadcasting a trafficannouncement (TA), the unit will seek onein another network and the system willreturn to stand-by mode.

Note: Audio from the currently tunedradio broadcast is muted while in TAstandby mode.

When a TA broadcast is received, the TAbroadcast will supersede other radio orCDplay. During a TAbroadcast, press thetraffic announcement button to end thebroadcast and return to the previousmode. To cancel the TA stand-by mode,press the traffic announcement buttonwhile the unit is in TA stand-by mode.

132

Audio unit operation

AUTOMATIC VOLUMECONTROL

The automatic volume control (ALC) is afeature that automatically adjusts audiovolume and sound quality according tothe vehicle speed. The volume rises withan increase in vehicle speed, and falls asvehicle speed decreases.

The following four modes are available.Select the desired mode.

VolumechangeMode

No changeALC OFF

MinimumALC LEVEL 1

MediumALC LEVEL 2

MaximumALC LEVEL 3

Turn the audio control dial to select theALC OFF, ALC LEVEL 1, 2 and 3 modes.The selected mode will be indicated.

ALTERNATIVEFREQUENCIES

Alternative frequency (AF) functions onFM stations. Press the alternativefrequency button to turn it on and 'AF' willbe displayed. When an RDS station isreceived, the station's name will then bedisplayed.

If you wish to continue a regionalprogramme, press the alternativefrequency button for two seconds until abeep is heard and 'REG ON' will bedisplayed. To cancel it, press thealternative frequency button again forabout two seconds until a beep is heardand 'REG OFF' will be displayed.

PRIORITY PROGRAMMETYPE (PTY)

Many programmes in the FM wavebandare categorised by the type of materialthey broadcast. This classification takesthe form of an identification numbercoded into the broadcast signal.

On designated units, searches can bebased on one of these classifications sothat you can choose to listen to aparticular type of programme.

DescriptionClassification

Pop musicPOP

Classical musicCLASSICS

NEWS

SPORTS

TALK

Not categorisedNONE

See note belowALARM

133

Audio unitmenus

Note: Some radio stations can alsotransmit emergency information underthe undocumented category of ALARMbut this programme type cannot beselected manually.

Selecting PTY

• Press the PTY button while in FMmode. ThePTYclassification codeand'PTY' will be displayed. If there is noPTY code then 'NONE' will bedisplayed.

Selecting stationswith thesameprogramme type

Press the PTY button and while the PTYcode is displayed:

• Use the SEEK UP/DOWN buttons tolocate other stations broadcastingprogrammes of the same type.

Selecting stationswithdifferent programme types

Press the PTY button and while the PTYcode is displayed:

• Press the PTY button again to selectanother programme type. Keeppressing PTY until you reach thedesired programme type.

• Then use the SEEK UP/DOWNbuttons to locate a stationbroadcasting the selectedprogramme type.

Using PTY

While the audio unit is searching foranother PTY station, a PTY search displayappears. The PTY code will flash duringthe search. When a programme is found,radio reception is restored from thestation selected.

If the new station is not required, while thePTY code is still flashing, press SEEKagainto find another station broadcasting thesame programme type.

Note: If a station transmitting the sametype of programme cannot be found,'NOTHING' is displayed and the radioreturns to the original station.

134

Audio unitmenus

LOADINGCOMPACTDISCS

Single CDplayer

Insert the CD into the slot, label-side up.The auto-loading mechanism will set theCD and begin play. There will be a shortlapse before play begins while the playerreads the digital signals on the CD.

6-disc in dashCDplayer

The CD must be label-side up wheninserting. The auto-loading mechanismwill set the CD and begin play. There willbe a short lapse before play begins whilethe player reads the digital signals on theCD. The disc number and the tracknumber will be displayed.

Note: The CD will begin playbackautomatically after insertion. ACD cannotbe insertedwhile the display reads 'WAIT'.A beeping sound can be heard during thiswaiting time. Simultaneously pressing thePOWER/VOLUME DIAL and the LOADbutton for about two secondswill turn thisbeeping sound ON or OFF.

To load a single CD:

• Press the LOAD button.

• When 'IN' is displayed, insert the CD.

You may insert a CD into a specific traynumber by following this procedure:

• Press and hold the LOAD button forabout two seconds until a beep soundis heard.

• Press the channel preset button forthe desired tray number while 'WAIT'is displayed.

• When 'IN' is displayed, insert the CD.

Note: The CD cannot be inserted to thedesired tray number if that tray is alreadyoccupied.

To loadmore than oneCD:

• Press and hold the LOAD button forabout two seconds until a beep soundis heard.

• When 'IN' is displayed, insert the CD.

• When 'IN' is displayed again, insert thenext CD.

Note: The first-insertedCDwill be playedautomatically when no other CD isinserted within 15 seconds after 'IN' isdisplayed, or when the CD trays are full.

EJECTINGCOMPACTDISCS

WARNING

Under certain operating conditionsit is possible for CDs to be verywarm when ejected. Take care

whilst removing.

Single CDplayer

• Press the CD eject button at any timeand remove the disc.

• Radio reception is restoredautomatically when the eject buttonis pressed.

6-disc in dashCDplayer

Normal ejection

• Press the CD eject button. The discnumber and 'DISC OUT' will bedisplayed.

• Pull out the CD.

Note:When the CD is ejected duringplay, the next CD will be playedautomatically.

135

Compact disc player

EjectingCDs froma specific traynumber

• Press and hold the CD eject buttonfor about two seconds until a beepsound is heard. The 'DISC OUT'display flashes.

• Press the channel preset button forthe desired CD number for less thanfive seconds after the beep sound isheard.

• Pull out the CD.

EJECTINGMULTIPLECOMPACTDISCS

• Press and hold the CD eject buttonfor about two seconds until a beepsound is heard. The 'DISC OUT'display flashes.

• Press theCDeject button againwithinfive seconds after the beep sound isheard.

• Pull out the CD, then the next CD willbe ejected.

• When all discs have been ejected andremoved, the radio reception isrestored.

Note: If the button is not pressed andabout five seconds have elapsed when'DISC OUT' is flashing, CDs areautomatically ejected.

Note: CDs will be ejected starting withthe one with the lowest number.

Note: All CDs in the tray will be ejectedcontinuously.

Note: CDs can be ejected when theignition switch is off. Press and hold theCD eject button for about two secondsand all CDs will eject.

COMPACTDISCPLAYBACK

During radio reception, press the CD playbutton once to start play when there is aCD in the unit.

If there isn't a CD in the unit when the CDplay button is pressed, 'NODISC' will flashon and off.

COMPACTDISCSELECTION

6-disc in dashCDplayer

When the CD play button is pressed,playbackwill recommence fromwhereverit was last stopped.

If that disc is no longer available, playbackwill start from the next disc and thencontinue in ascending order, i.e. disc threefollows disc two. When the disc in thehighest loading position has been played,playback will continue with the disc in thelowest loading position and go throughthe same cycle.

You can, however, switch to a disc of yourchoice by pressing theDISCUPor DOWNbuttons during playback.

The audio unit remembers which discsare available so it will not select a disc thatit knows to be missing. If you select amissing disc using the DISC UP or DOWNbuttons, ‘NO DISC’ will be displayed andplayback will continue from the currentdisc.

Note: To change the disc during MP3playback, press and hold the DISC UP orDOWN buttons for about two seconds.

136

Compact disc player

TRACKSELECTION

• Press the TRACK UP button once tomove to the next track or press itrepeatedly to access later tracks.

• Press the TRACKDOWNbutton onceto replay the current track.

• Press the TRACK DOWN buttonrepeatedly to select previous tracks.

FAST FORWARD/REVERSE

• Press and hold the left/right arrowbuttons to search backwards orforwardswithin the tracks on the disc.

SHUFFLE/RANDOM

Random track playback, also known asshuffle, plays all tracks on the CD inrandom order.

Duringmusic CDplayback

• Press the random button (RDM)during playback to play the tracks inthe CD randomly. 'RDM' is displayed.

• Press the button again to cancel therandom play.

DuringMP3CDplayback(folder random)

• Press the random button (RDM)during playback to play the tracks inthe folder randomly. 'FOLDER RDM'is displayed.

• To cancel the random play, press thebutton again after three seconds.

DuringMP3CDplayback (CDrandom)

• Press the random button (RDM)during playback, and then press thebutton again within three seconds toplay the tracks in the CD randomly.'DISC RDM' is displayed.

• Press the button again to cancel therandom play.

REPEATCOMPACTDISCTRACKS

Duringmusic CDplayback

• Press the repeat button (RPT) duringplayback to play the current trackrepeatedly. 'RPT' is displayed.

• Press the button again to cancel therepeat play.

DuringMP3CDplayback(trackrepeat)

• Press the repeat button (RPT) duringplayback to play the current trackrepeatedly. 'TRACKRPT' is displayed.

• To cancel the repeat play, press thebutton again after three seconds.

DuringMP3CDplayback(folder repeat)

• Press the repeat button (RPT) duringplayback, and then press the buttonagainwithin three seconds to play thetracks in the current folder repeatedly.'FOLDER RPT' is displayed.

• Press the button again to cancel therepeat play.

137

Compact disc player

MP3FILE PLAYBACK

MP3 (MPEG 1 Audio Layer-3) is astandard technology and format forcompressing audio data. This allows amore efficient use of the media.

You can play MP3 files recorded onCD-ROMs,CD-Rs, andCD-RWs. Thediscmust be in the ISO 9660 level 1 or level 2format, or Joliet or Romeo in theexpansion format.

ISO9660 format

This is the most common internationalstandard for the logical format of files andfolders on a CD-ROM.

It is divided into three separate levelsbased on differences in file namingprocedures, data configuration and othercharacteristics.

Bit rate

This refers to the volume of data persecond, expressed in bps (bits persecond). Generally, the larger the numberof the transfer bit ratewhen compressingan MP3 file, the more informationregarding musical reproduction it carries,and therefore the better the soundquality.

This unit can playMP3 files that have beenrecorded in bit rates of 8 kbps to 320kbps. Nonetheless, to ensure enjoymentof music with consistent sound quality, itis recommended to use discs that havebeen recorded at a bit rate of 128 kbpsor more.

Multi session

A session is the complete amount of datarecorded from the beginning to the endof a single period of CD-ROM,CD-R/CD-RW data recording.Multi-session refers to the existence ofdata from two or more sessions on asingle disc. You can use a disc recordedin Multi Session containing up to 40sessions.

File formats

• With formats other than ISO9660 level1 and level 2, folder names or filenamesmaynot bedisplayedcorrectly.

• When naming, be sure to add the fileextension “.MP3” to the file name.

• If you put the extension “.MP3” to afile other than MP3, the unit cannotrecognize the file properly and willgenerate random noise that coulddamage your speakers.

• The following discs take a longer timeto start playback.• a disc recorded with complicated

tree structure.• a disc recorded in Multi Session.

• a non-finalised disc to which datacan be added.

Themaximumnumber of characters thatcan be used for file names is as follows.However, this unit will only display up to30 characters, including the file extension(.mp3).

Maxnumber ofcharactersinafilename including'.mp3' extension

12*ISO 9660 level 1

31*ISO 9660 level 2

138

Compact disc player

Maxnumber ofcharactersinafilename including'.mp3' extension

64Joliet extendedformat

128Romeo extendedformat

*English one-byte characters (capitalizedonly) and underscore '_' are available.

MP3 files playback order

The playback order of the folders and filesis as shown.

Note: A folder that does not include anMP3 file is skipped.

-

E83712

Level 1A

Level 2B

Level 3C

Level 4D

This unit will playMP3 files that have up toeight levels. However, the more levels adisc has, the longer it will take to initiallystart playing. It is recommended to recorddiscs with two levels or less.

A single disc with up to 512 files can beplayed and a single folder with up to 255files can be played.

139

Compact disc player

ID3 tag display

ID3 tag is amethod for storing informationrelated to the music in an MP3 file.Information such as track, artist and albumname can be stored. This content can befreely edited using ID3 editing functionsoftware.

This unit can only display ID3 Tag album,track and artist names that have beeninput using Ver1.0/1.1/2.2/2.3 formats. Anyother data that may have been inputcannot be displayed.

This unit can only display English (includingnumerals) one-byte characters. Use onlyEnglish (including numerals) one-bytecharacters when inputting ID3 tags.Two-byte characters and some specialsymbols cannot be displayed.

MP3navigation

MP3 tracks may be recorded on the CDin several ways. They can all be placed inthe root directory like a conventional audioCD, or they can be placed in folders thatmay represent, for example, an album, anartist, or a genre.

The playing sequence on CDs withmultiple folders is to play the tracks fromshallow to deep as shown in the folderillustration. The folder playback order isautomatically set and this order cannotbe changed.

• Press the DISC UP/DOWN buttons toselect another folder.

• Press the TRACK UP/DOWN buttonsto select another track (file) within thefolder.

MP3DISPLAYOPTIONS

When an MP3 disc is playing, certaininformation encoded in each track can bedisplayed. Such information will normallyinclude:

• The file name

• The folder name

• ID3 information which might be thealbum or artist’s name

The unit will normally show the file namethat is playing. To select one of the otheritems of information:

• Press the DISPLAY button repeatedlyuntil the information required is shown.

• If the information selected isunavailable, ‘NO TITLE’ appears in thedisplay.

ScrollingMP3displays

Only 12 characters can be displayed atone time. To display the rest of thecharacters of a long title, turn the AUDIOCONTROL/MANUAL TUNING dial to theright. Hidden titles can be scrolled into thedisplay one character at a time.

Note: The displayable number ofcharacters is limited. If the number ofcharacters, including the file extension(.mp3), exceeds 32 characters, itmay notbe fully displayed.

CD text display options

When an audio disc with CD text isplaying, limited information encoded ineach track can be displayed. Suchinformation will normally include:

• The disc name

• The artist name

• The track name

These display options are selected in thesame way as MP3 displays.

140

Compact disc player

AUXILIARY INPUT (AUX IN)SOCKET

Note: For optimum performance whenusing any auxiliary device set the volumeon the device high. This will reduce audiointerference when charging the devicevia the vehicle power supply socket.

When fitted the Auxiliary input (AUX IN)socket permits an auxiliary device, suchas an MP3 player, to be linked into thevehicle audio system. Output can beplayed through the vehicle speakers.

To connect an auxiliary device, plug it intothe AUX IN socket using a 3.5 mmconventional audio jack connector.

Select the auxiliary input via the AUXbutton andplaybackwill be heard throughthe vehicle speakers. LINE IN or LINE INACTIVE will appear in the vehicle audiounit display. Volume, treble and bass canbe adjusted on the vehicle audio unit asnormal.

The vehicle audio unit buttons can alsobe used to restore playback from thevehicle audio unit, while the auxiliarydevice remains connected.

141

Auxiliary input (AUX IN) socket

ANTENNA

The radio aerial is mounted on the roof ofthe vehicle above the front pillar. It ismanually operated and must be raisedand lowered by hand.

CAUTION

To prevent damage to the aerial,retract it before entering a car washor passing beneath a low overhead

clearance.

142

Audio systemcare

AUDIO TROUBLESHOOTING

RectificationAudio unit display

Flashing message to prompt the user for the securitycode. Displayed at power on after audio unit has hadbattery power supply interrupted. Enter code as

described in chapter entitled Audio system security.

CODE

Message to inform the user there has been an errormade during security code setup. Follow instructions

as described in chapter Audio system security.

ERR

Flashing message to inform user that radio securitysystem has locked the radio after repeated incorrect

security code inputs. Contact your Ford dealer.

ERR

General error message for CD fault conditions, suchas cannot read the CD, data-CD inserted, etc. Ensuredisc is loaded correct way up. Clean and re-try, orreplace disc with known music disc. If error persists

contact your Ford dealer.

CHECK CD

143

Audio troubleshooting

ELECTROMAGNETICCOMPATIBILITY

WARNINGSYour vehicle has been tested andcertified to European legislationsrelating to electromagnetic

compatibility (2004/104/EC). It is yourresponsibility to ensure that anyequipment you have fitted complies withapplicable local legislations. Have anyequipment fitted by properly trainedtechnicians.

WARNINGSRadio frequency (RF) transmitterequipment (e.g. cellular telephones,amateur radio transmitters etc.)may

only be fitted to your vehicle if they complywith the parameters shown in the tablebelow. There are no special provisions orconditions for installations or use.

Do not mount any transceiver,microphones, speakers, or anyother item in the deployment path

of the airbag system.

Do not fasten antenna cables tooriginal vehicle wiring, fuel pipes andbrake pipes.

Keep antenna and power cables atleast 100mm from any electronicmodules and airbags.

E113716

1

3

2

4

AntennaPositionsMaximumoutput powerWatt(PeakRMS)

FrequencyBandMHz

3, 450 W3.5 – 30

1, 2, 3, 450 W30 – 54

1, 2, 3, 450 W68 – 87.5

1, 2, 3, 450 W142 – 176

1, 2, 3, 450 W380 – 470

144

Appendices

AntennaPositionsMaximumoutput powerWatt(PeakRMS)

FrequencyBandMHz

1, 2, 3, 410 W806 – 940

1, 2, 3, 410 W1200 – 1300

1, 2, 3, 410 W1710 – 1885

1, 2, 3, 410 W1885 – 2025

In the cabin0.1 W12400 – 2500

1Only for Bluetooth.

Note: After the installation of RFtransmitters, check for disturbances fromand to all electrical equipment in thevehicle, both in the standby and transmitmodes.

Check all electrical equipment:• with the ignitionON• with the engine running

• during a road test at various speeds.

Check that electromagnetic fieldsgenerated inside the vehicle cabin by thetransmitter installed donot exceedhumanexposure limits specified in EU directive2004/40/EC.

145

Appendices

146

AA/CSee: Climate control....................................48

About this handbook................................5ABSSee: Brakes...................................................72

ABS driving hintsSee: Hints on driving with ABS...................72

AccessoriesSee: Parts and accessories..........................6

Adjusting the steering wheel.................24Air conditioningSee: Climate control....................................48

Air vents....................................................48Alarm.........................................................23Principle of operation...................................23

All-wheel drive (AWD).............................67Vehicles with automatic transmission.......69Vehicles with manual transmission............67

Alternative frequencies.........................133Antenna...................................................142Appendices............................................144Arming the alarm.....................................23Perimeter alarm............................................23

Arming the engine immobiliser.............22Ashtray......................................................59Audible warnings and indicators...........47Door open warning......................................47Lights on warning.........................................47

Audio introduction.................................122Audio menu control..............................130Beep setting.................................................131

Audio system care................................142Audio system security..........................127Audio troubleshooting..........................143Audio unit clock and date displays.....129Audio unit menus..................................133Audio unit operation..............................130Audio unit overview...............................123Button function overview..........................125

Automatic transmission..........................70Drive modes...................................................71Hints on driving with an automatictransmission...............................................71

Selector lever positions...............................70Automatic volume control....................133Autostore control...................................131

Auxiliary input (AUX IN) socket...............61Auxiliary power sockets.........................59AWDSee: All-wheel drive (AWD).........................67

BBattery care............................................103Bonnet lockSee: Opening and closing the bonnet......94

Booster cablesSee: Using booster cables........................103

Booster cushions.....................................14Booster cushion (Group 3)..........................14Booster seat (Group 2)................................14

Brake and clutch fluid check.................98Brakes.......................................................72Principle of operation...................................72

Bulb changingSee: Changing a bulb..................................29

Bulb specification chart..........................34

CCar washSee: Cleaning the exterior.........................101

Catalytic converter..................................64Driving with a catalytic converter...............64

Changing a bulb......................................29Exterior mirror lamps....................................31Footwell lamps..............................................34Front fog lamps.............................................31Front interior lamps......................................33Front reading lamps.....................................33Headlamp main and dipped beam...........30Number plate lamp......................................33Rear fog lamp...............................................32Rear interior lamps.......................................33Rear lamps.....................................................31Side lamps and front directionindicators...................................................30

Side repeaters...............................................31Changing a fuse......................................86

147

Index

Changing a road wheel........................105Fitting a wheel.............................................109Jacking points.............................................107Removing a wheel......................................108Spare wheel.................................................105Stowing the wheel.......................................110Vehicle jack..................................................106

Changing the remote controlbattery.....................................................19

Changing the wiper blades...................26Checking the wiper blades...................25Child safety...............................................12Child safety locks.....................................15Child seat positioning..............................13Child seats................................................12Child restraints for different massgroups........................................................12

Cigar lighter..............................................59Cleaning the exterior.............................101Body paintwork preservation....................101Cleaning the chrome trim..........................101Cleaning the headlamps............................101Cleaning the rear window..........................101

Cleaning the interior...............................101Instrument cluster screens, LCD screens,radio screens..........................................102

Seat belts......................................................101Climate control........................................48Principle of operation...................................48

Clock.........................................................59Coded keys.............................................22Cold weather precautions.....................82Compact disc playback.......................136Compact disc player.............................135Compact disc selection.......................1366-disc in dash CD player...........................136

Convenience features............................59Coolant checkSee: Engine coolant check.........................97

Cup holders.............................................60Front cup holders.........................................60Rear cup holders..........................................60

DDetachable tow ball................................79Driving with a trailer......................................80Driving without a trailer................................80Inserting the tow ball arm............................79Maintenance..................................................81Removing the tow ball arm........................80Unlocking the tow ball armmechanism...............................................79

Direction indicators.................................28Disarming the alarm................................23Perimeter alarm............................................23

Disarming the engine immobiliser........22Draining the fuel filter water trap...........98Driving hints..............................................82

EEjecting compact discs........................1356-disc in dash CD player...........................135Single CD player..........................................135

Ejecting multiple compact discs ........136Electric exterior mirrors..........................36Electric folding mirrors.................................36

Electric windows.....................................35Driver’s door switches.................................35Front and rear passengers’ doorswitches....................................................35

Opening and closing the windowsautomatically.............................................35

Safety switch for the passengerwindows....................................................35

Electromagnetic compatibility.............144Emergency equipment..........................83Engine compartment overview - 2.5LDuratorq-TDCi (WL) Diesel/3.0LDuratorq-TDCi (WL) Diesel.................95

Engine coolant check.............................97Checking the coolant level.........................97Topping up the coolant...............................97

Engine immobiliser..................................22Principle of operation...................................22

Engine oil check......................................96Checking the oil level...................................96Topping up the oil.........................................96

148

Index

Entering a security code......................127Cancelling the code number....................128Changing the code number.....................128Setting procedure.......................................127System activation.......................................128

Exterior mirrors........................................36Manual folding mirrors.................................36

FFastening the seat belts..........................17Fast forward/reverse............................137First aid kit.................................................83Double cab....................................................83Single cab......................................................83Stretch cab....................................................83

Fog lampSee: Front fog lamps....................................27

Front fog lamps.......................................27Front seats...............................................55Adjusting the angle of the seatback.........56Moving the seats backwards andforwards....................................................55

Fuel and refuelling...................................64Technical specifications..............................65

Fuel consumptionSee: Technical specifications.....................65

Fuel filler flap.............................................65Fuel quality - Diesel.................................64Long-term storage......................................64

Fuse box locations..................................85Auxiliary fuse box..........................................85Central fuse box...........................................86Inclinometer and compass fuse................86

Fuses.........................................................85Fuse specification chart.........................87Auxiliary fuse box..........................................89Central fuse box...........................................87Inclinometer and compass fuse................90

GGauges.....................................................38Compass.......................................................39Declination table............................................41Engine coolant temperature gauge..........38Fuel gauge.....................................................38Inclinometer and compass.........................39Odometer and tripmeter............................38Pitch inclinometer.........................................39Programming the inclinometer andcompass....................................................39

Roll inclinometer...........................................39GearboxSee: Transmission........................................67

General driving points............................82Vehicles with a diesel engine......................82

General information on radiofrequencies............................................19

Glove box.................................................60

HHandbrakeSee: Parking brake.......................................72

Hazard warning flashers........................28Headlamp levelling..................................28Head restraints........................................56Adjusting the head restraint.......................56Removing the head restraint......................56

Heated seats...........................................58Heated windows and mirrors...............53Heated exterior mirrors...............................54Heated rear window....................................53

HeatingSee: Climate control....................................48

Hints on driving with ABS.......................72

IIgnition switch..........................................62ImmobiliserSee: Engine immobiliser..............................22

Important audio information................122Audio unit labels..........................................122Disc labels....................................................122

Incorrect security code........................128Instrument lighting dimmer...................59

149

Index

Instruments..............................................38Interior lamps...........................................29Courtesy lamp..............................................29Reading lamps..............................................29

Introduction................................................5

JJump startingSee: Using booster cables........................103

KKeys and remote controls......................19

LLighting control........................................27Headlamp flasher.........................................27Lighting control positions............................27Main and dipped beam...............................27

Lighting......................................................27Load carriersSee: Roof racks and load carriers.............76

Load carrying...........................................75General information.....................................75

Loading compact discs........................1356-disc in dash CD player...........................135Single CD player..........................................135

Load retaining fixtures............................75Load rest........................................................76Rope hooks...................................................75

Locking and unlocking...........................20Locking and unlocking the doors with thehandles.......................................................21

Locking and unlocking the doors with thekey..............................................................20

Locking and unlocking the doors with theremote control..........................................20

Locks.........................................................20Lost security code.................................127

MMaintenance............................................93General information.....................................93Technical specifications..............................99

Manual climate control...........................48Air conditioning.............................................52Air distribution control..................................49Blower............................................................50Defrosting and demisting the windscreenquickly........................................................50

Heating the interior quickly..........................51Recirculated air.............................................50Temperature control....................................49Ventilation.......................................................51Warm-up system.........................................48

Manual transmission...............................67MirrorsSee: Heated windows and mirrors...........53See: Windows and mirrors.........................35

MP3 display options..............................140CD text display options..............................140Scrolling MP3 displays...............................140

MP3 file playback..................................138.......................................................................138

OOccupant protection...............................16Principle of operation....................................16

Oil checkSee: Engine oil check..................................96

On/off control.........................................130

See: Opening and closing the bonnet......94

OOpening and closing the bonnet..........94Closing the bonnet......................................94

PParking aid................................................73Principle of operation...................................73

Parking aidSee: Using the parking aid..........................73

Parking brake...........................................72Applying the parking brake.........................72Parking on a hill.............................................72Releasing the parking brake.......................72

Parts and accessories..............................6

150

Index

Power steering fluid check....................97Topping up.....................................................97

Priority programme type (PTY)...........133Selecting PTY..............................................134Selecting stations with differentprogramme types..................................134

Selecting stations with the sameprogramme type....................................134

Using PTY.....................................................134

QQuick start...................................................7Auxiliary power sockets................................11Instrument cluster...........................................9Instrument panel overview - LHD................7Instrument panel overview - RHD................8Locking and unlocking.................................10Warning lamps and indicators....................10

RRear fog lamps........................................27Rear loadspace hatches........................75Rear quarter windows............................37Rear seats................................................57Folding the rear seatback - Doublecab..............................................................57

Folding the rear seats - 4-door stretchcab..............................................................57

Rear seat arm rest.......................................57Reduced engine performance.............82Refuelling..................................................65Remote control batterySee: Changing the remote controlbattery........................................................19

Repairing minor paint damage............102Repeat compact disc tracks...............137During MP3 CD playback (folderrepeat)......................................................137

During MP3 CD playback (trackrepeat)......................................................137

During music CD playback........................137Roof racks and load carriers.................76Roof rack.......................................................76

Running-in................................................82Brakes and clutch........................................82Engine............................................................82Tyres...............................................................82

SSafety precautions..................................64Filling fuel containers....................................64

Seat beltsSee: Fastening the seat belts......................17

Seats.........................................................55Security code.........................................127Setting the clock on the audiounit.........................................................129.......................................................................12912/24 hour format.......................................129Changing the time......................................129Exact hour adjustment..............................129

Shuffle/random......................................137During MP3 CD playback (CDrandom)....................................................137

During MP3 CD playback (folderrandom)....................................................137

During music CD playback........................137Sitting in the correct position.................55Snow chainsSee: Using snow chains..............................111

Starter switchSee: Ignition switch......................................62

Starting a diesel engine..........................62Cold or hot engine.......................................62

Starting the engine.................................62General information.....................................62

Station preset buttons..........................130Station tuning control............................130Manual tuning..............................................130Seek tuning..................................................130

Steering wheel lock................................62Steering wheel.........................................24Storage compartments..........................61Switching off the engine........................63Vehicles with a turbocharger.....................63

Symbols glossary......................................5Symbols in this handbook.............................5Symbols on your vehicle...............................5

151

Index

TTechnical specifications........................113Technical specifications..............................113

Towing a trailer.........................................78Steep gradients............................................78Technical specifications...............................78

Towing points...........................................91Front tow point..............................................91Rear tow point...............................................91

Towing the vehicle on four wheels.......91Towing.......................................................78Track selection.......................................137Traffic information control.....................131Transmission............................................67Transporting the vehicle.........................92Tyre care..................................................110Tyre pressuresSee: Technical specifications.....................111

TyresSee: Wheels and tyres...............................105

UUsing booster cables............................103To connect the booster cables................103To start the engine.....................................104

Using seat belts during pregnancy.......18Using snow chains..................................111Using the parking aid..............................73Switching the parking aid on and off.........74

Using winter tyres..................................110

VVehicle battery.......................................103Vehicle care.............................................101Vehicle identification number (VIN)......112Vehicle identification plate.....................112Vehicle identification..............................112Vehicle recovery......................................91VentilationSee: Climate control....................................48

VentsSee: Air vents................................................48

VINSee: Vehicle identification number(VIN)...........................................................112

Volume control.......................................130

WWarning lamps and indicators..............44ABS warning lamp........................................44Airbag warning lamp....................................45Brake system lamp......................................45Direction indicator........................................46Door open warning lamp............................45Engine warning lamp...................................45Four-wheel drive indicator..........................46Four-wheel drive low (4L) indicator ..........46Front fog lamp indicator..............................46Headlamp indicator......................................46Ignition warning lamp...................................45Low fuel level warning lamp.......................45Main beam indicator....................................46Oil pressure warning lamp..........................45Overdrive off (O/D OFF) indicator..............46Rear fog lamp indicator...............................46Remote free wheel (RFW) indicator.........46Vehicle speed alarm indicator....................46Water-in-fuel indicator lamp.......................45

Warning triangle......................................83Double cab....................................................84Single cab......................................................83Stretch cab....................................................83

Washer fluid check.................................98WashersSee: Wipers and washers...........................25

WashingSee: Cleaning the exterior.........................101

Waveband button..................................131Wheels and tyres...................................105General information....................................105Technical specifications..............................111

Windows and mirrors.............................35Windscreen washers.............................25Windscreen wipers.................................25Intermittent wipe..........................................25

Winter tyresSee: Using winter tyres...............................110

Wipers and washers...............................25

152

Index

Feel the difference

(CG3350en)