DOC053.52.00139.Jan06

PHOSPHAX scData Sheet

1

DOC053.52.00139.Jan06Data SheetPHOSPHAX sc

Technical data

We reserve the right to make changes without notice.

FusesConnect a maximum of 2 analysis instruments to one sc1000.

Always connect a residual current circuit breaker between mains and system in case of external supply of power.

If you operate controller and / or analysis instrument outdoors, provide overvoltage protection between mains and system in case of external power supply.

Ambient conditions, limits for operation and storageFor information on the ambient conditions, limits for operation and storage, temperatures, atmospheric humidity, dust, etc. please see the technical data, the stickers on the related modules or the rating plates on the related modules.

Table 1 PHOSPHAX sc specifications (in some cases optional extra)

Enclosure material ASA/PC UV-resistant

Measuring method 2-beam photometer (yellow method)

Measuring range0.05...15 mg/l PO4–P 1...50 mg/l PO4–P

With different verification limits and resolutions

Verification limit 0.05 mg/l, with standard solution 1.00 mg/l, with standard solution

Measuring accuracy(with standard solution) 2 % of the measured value + 0.05 mg/l 2 % of the measured value + 1.0 mg/l

Reproducibility(with standard solution)

2 % of the measured value + 0.05 mg/l, 2 % of the measured value + 1.0 mg/l,

Response time (90 %) < 5 minutes

Adjustable measuring interval 5...120 minutes

Power supply Power supply with power cable only using the sc1000 controller(analyser, filtration probe sc and drain tubing: 115 V versions or 230 V versions)

Data transmission Data transmission with data cable on the sc1000 controller

Electrical power, power consumption: 400 VA (mean), max. 1000 VA (with 10 m heated filtration probe tubing)

Electrical fuse protection Via sc1000 controller

Outputs Relay, current outputs, bus interface via sc1000 controller

Operating temperature –20 °C...40 °C (–4 °F...104 °F); 95 % relative humidity, non-condensing

Storage temperature –20 °C...50 °C (–4 °F...122 °F; 95 % relative humidity, non-condensing

Sample temperature +4 °C...+ 45 °C (39 °F...113 °F)

Permissible pH value of the sample 5...9

Dimensions (W × H × D) 540 × 720 × 390 mm (21.25 × 28.35 × 15.35 inches)

Cable lengths for data and power cable 2 m (80 inches) (from edge of enclosure)

Mass PHOSPHAX sc Approx. 31 kg, without filtration probe sc and without chemicals

2

Emissions

CAUTIONDepending on the frequency of cleaning and calibration, a varying quantity of lyes and acids will be produced. The lyes and acids are toxic, caustic and/or an irritant. Ensure only trained personnel handle these residues and that the applicable accident prevention regulations are observed.

Wear personal safety clothing when handling chemicals and sample flows of unknown composition!

Dispose of these substances left over from cleaning and calibration correctly and in accordance with the applicable regulations.

3

Drawing with dimensions

Figure 1 Drawing with dimensions

523 mm[20.47 in.]

400 mm[15.75 in.]

466 mm[18.11 in.]

71

0m

m[2

7.5

in.]

280 mm[11.02 in.]

40 mm[1.57 in.]

282 mm [11.1 in.]

1040 mm[40.94 in.]

85

0m

m[3

3.1

5in

.]

242 mm [9.53 in.]

4

Replacement parts, consumables, accessories

PHOSPHAX sc chemistryDescription 1 Description 2 Order No.

Reagent PHOSPHAX sc (2 L) for all measuring ranges LCW869

Cleaning solution PHOSPHAX sc (1 L) for all measuring ranges LCW870

Replacement partsItem Description 1 Description 2 Order No.

1 Door for sc-analyser enclosure incl. 4 instrument labels LZY143

1 Set of instrument labels (4 pieces) LZY144

2 Door catch LZY148

3 Enclosure for sc-analyser without door LZY145

4 Set of filter pads (2 pieces) LZY154

5 Clamping lock for sc-analyser LZY147

6 Fence incl. screws M3 x 6 LZY157

7 Compressor switchable 115 V/230 V LZY149

8 Air tubing for compressor incl. non-return valve, fitting, LZY151

9 Fan for incoming air LZY152

10 Collecting tray for sc-analyser LZY146

11 Hinge incl. screws LZY155

12 Gasket for door of sc-analyser LZY187

13 Door lock sc-analyser LZY188

14 Mounting plate for sc-analyser LZY161

15 Analytical section of PHOSPHAXsc MR: 0.05-15 mg/l LZY163

16 Analytical section of PHOSPHAXsc MR: 1-50 mg/l LZY164

17 Measuring cell PHOSPHAX sc MR: 0.05 -15 mg/l LZY185

18 Measuring cell PHOSPHAX sc MR: 1 -50 mg/l LZY186

19 Valve block PHOSPHAX sc incl. valves; MR: 0.05 -15 mg/l LZY183

20 Valve block PHOSPHAX sc incl. valves; MR: 1 -50 mg/l LZY160

21 Valve block PHOSPHAX sc MR: 0.05 -15 mg/l LZY271

22 Valve block PHOSPHAX sc MR: 1 -50 mg/l LZY272

23 Upper part of valve block LZY174

24 Upper part of valve block with valve LZY175

25 Valve 2/2 ways LZY168

26 Tubing 3.2 mm (2 m) sc-analyser LZY195

27 Set of fittings 3.2 mm (4 pieces) LZY111

28 Fitting for tubing DN4/6 LZY134

29 Blind plug LZY193

30 Valve block 2-channel switch incl. valve for sc-analyser LZY267

31 Valve block 2-channel switch for sc-analyser LZY172

32 Valve 3/2 ways LZY171

33 Conversion kit from 1-channel > filtration probe sc-analyser AMTAX sc/PHOSPHAX sc LZY242

34 Bottom part of overflow vessel LZY165

5

35 Upper part of overflow vessel LZY166

36 Upper part of overflow vessel incl. valve LZY167

37 Locking screw LZY150

38 Conversion kit from filtration probe > 1-channel sc-analyser AMTAX sc/PHOSPHAX sc LZY241

39 Upper part of overflow vessel for 1 or 2-channel instrument LZY268

40 Overflow vessel for 2-channel instrument LZY269

41 Safety plate for sc-analyser LZY179

42 Insulation cover for photometer PHOSPHAX sc MR 0.05-15 mg/l LZY225

43 Insulation cover for photometer PHOSPHAX sc MR 1-50 mg/l LZY226

44 Holder for piston pump LZY180

45 Pump head for air pump 10 mL LZY181

46 Piston pump for sc-analyser LZY177

47 Cover for reagent pump LZY178

48 Set of fittings 1.6 mm (4 pieces) LZY192

49 Tubing 1.6 mm (2 m) sc-analyser LZY194

50 Reagent pump for sc-analyser (valve pump) LZY176

51 Fan for air recirculation for sc-analyser LZY153

52 Heating for analyser enclosure incl. connectors LZY156

53 Cover LZY270

54 Cover for processor card LZY159

55 Cover for power supply LZY158

56 Power supply 100-240 V AC XMU434 YAB039

57 Amplifier card for PHOSPHAX sc YAB045

58 Processor card for sc-analyser OAB028, ZBA803 YAB043

59 Set of seals for PHOSPHAX sc measuring cell (4 O-rings) LZY197

60 Sealing for valve block LZY199

61 Sealing for overflow vessel LZY198

62 Card with temperature sensor AMTAX sc/PHOSPHAX sc YAB089

17+19+42 Conversion kit PHOSPHAX sc from HR to LR LZY313

18+20+43 Conversion kit PHOSPHAX sc from LR to HR LZY312

30+40 Conversion kit from 1-channel into 2-channel sc-analyser LZY170

AccessoriesDescription 1 Description 2 Order No.

Set of plugs (rubber) for sc-analyser (3*type 1, 1*type 2, 3*type 3) LZY007

Accessories for AMTAX/PHOSPHAXsc for continuous sampling (1/2-channel) LZY189

Cutter for tubing LZY201

Special tool for electrode AMTAX sc LZY200

Heated drain/connecting hose 230 V LZY302

Heated drain/connecting hose 115 V LZY303

Set of connectors for sc-analysers LZY190

Set of screws for sc-analyser 4 x M3x6, 2 x M3x25; 2 x M3x50 LZY191

Replacement parts (continued)Item Description 1 Description 2 Order No.

6

FasteningDescription 1 Description 2 Order No.

Wall mounting kit 4 screws 5*60 incl. 4 anchors LZX355

Mounting kit for sc-analyser incl. fastening and angle bracket, screws LZY044

Set of screws for fastening and angle bracket LZY216

Set of screws for sc-analyser LZY223

Set of screws for rail mounting LZY285 and LZY316 LZY220

Rail mounting for analyser with controller LZY285

Rail mounting for analyser without controller LZY316

Stand mounting for sc-analyser with controller LZY286

Stand mounting for sc-analyser without controller LZY287

7

8

9

10

11

Contact

HACH LANGE GmbH

Willstätterstraße 11D-40549 DüsseldorfTel. +49 (0) 211- 52 88 - 0Fax +49 (0) 211- 52 88 - 143info@hach-lange.dewww.hach-lange.de

HACH LANGE LTDPacific WaySalfordManchester, M50 1DLTel. +44 (0)161 8 72 14 87Fax +44 (0)161 8 48 73 24info@hach-lange.co.ukwww.hach-lange.co.uk

HACH LANGEHACH SAS33, Rue du BallonF-93165 Noisy Le GrandTél. +33 (0)1 48 15 68 70Fax +33 (0)1 48 15 80 00info@hach-lange.frwww.hach-lange.fr

DR. BRUNO LANGEGES. MBHIndustriestraße 12A-3200 ObergrafendorfTel. +43 (0) 2747 - 74 12Fax +43 (0) 2747 - 42 18info@hach-lange.atwww.hach-lange.de

DR. BRUNO LANGE AG

Juchstrasse 1CH-8604 HegnauTel. +41 (0)44- 9 45 66 10Fax +41 (0)44- 9 45 66 76info@hach-lange.chwww.hach-lange.ch

HACH LANGE SA

Motstraat 54B-2800 MechelenTél. +32 (0)15 42 35 00Fax +32 (0)15 41 61 20info@hach-lange.bewww.hach-lange.be

DR. LANGE NEDERLAND B.V.Laan van Westroijen 2aNL-4003 AZ TielTel. +31(0)3 44 63 11 30Fax +31(0)3 44 63 11 50info@hach-lange.nlwww.hach-lange.nl

HACH LANGE ABVinthundsvägen159ASE-128 62 SKÖNDALTel. +46 (0)8 7 98 05 00Fax +46 (0)8 7 98 05 30info@hach-lange.sewww.hach-lange.se

HACH LANGE A/SÅkandevej 21DK-2700 BrønshøjTel. +45 36 77 29 11Fax +45 36 77 49 11info@hach-lange.dkwww.hach-lange.dk

HACH LANGE S.L.U.C/Araba 45, Apdo. 220E-20800 Zarautz/GuipúzcoaTel. +34 9 43 89 43 79Fax +34 9 43 13 02 41info@hach-lange.eswww.hach-lange.es

HACH LANGE SP.ZO.O.ul. Opolska 143 aPL-52-013 WroclawTel. +48 71 3 42 10-81Fax +48 71 3 42 10-79info@hach-lange.plwww.hach-lange.pl

HACH LANGE S.R.L.Via Riccione, 14I-20156 MilanoTel. +39 02 39 23 14-1Fax +39 02 39 23 14-39info@hach-lange.itwww.hach-lange.it

HACH LANGE S.R.O.Lešanská 2a/1176CZ-141 00 Praha 4Tel. +420 272 12 45 45Fax +420 272 12 45 46info@hach-lange.czwww.hach-lange.cz

HACH LANGE S.R.O.Sabinovská 10SK-821 02 BratislavaTel. +421 2 4820 9091Fax +421 2 4820 9093info@hach-lange.skwww.hach-lange.sk

HACH LANGE LDARua dos Malhões,Edif. D. Pedro IP-2770-071 Paço D'ArcosTel. +351 210 00 1750Fax +351 210 00 8140info@hach-lange.ptwww.hach-lange.pt

HACH LANGE S.R.L.str. Aviator Teodor Iliescu nr.37Bucuresti, Sector 1RO-011672Tel. +40 (0)21 2 08 95 78Fax +40 (0)21 2 08 95 78info@hach-lange.comwww.hach-lange.com

HACH LANGE KFT.

Íves u. 2.H-9027 GyőrTel. +36 (06)96 511 400Fax +36 (06)96 329 981info@hach-lange.comwww.hach-lange.hu

HACH LANGE

8, Kr. Sarafov str.BG-1164 SofiaTel. +359 (0)2 963 19 21Fax +359 (0)2 866 04 47info@hach-lange.comwww.hach-lange.com