D3 K XL CAT.SIS ELECTRICO.pdf

1

2 200-L32 BK-14

AG-C4111-7898

L-C123E-5179

C-C4130-6795

9X-1123Component Part Number

Single Wire Connector

SocketPin

AG-C3130-6795

Pin or Socket Number

Wire, Cable, or Harness Assembly Identification:Includes Harness Identification Letters and Harness Connector Serialization Codes Harness Connector Serialization Code: The "C" stands

for "Connector" and the number indicates which connector in the harness. (C1, C2, C3, .....)

Part Number For Connector Recepticle

Part Number forConnector Plug

Harness Identification Letter(s):(A, B, C, ..., AA, AB, AC, ...)

Plug

GroundConnection

325-AG135 PK-14

Circuit IdentificationNumber Wire Color

Wire Gauge

Harness identification code: This example indicates wire 135 in harness "AG".

T

Ground (Case): This indicates that the component does not have a wire connected to ground. It is grounded by being fastened to the machine.

Ground (Wired): This indicates that the component is connected to a grounded wire. Thegrounded wire is fastened to the machine.

T

Switch (Normally Open): A switch that will close at a specified point (temp, press, etc.). The circle indicates that the component has screw terminals and a wire can be disconnected from it.

Receptacle

Switch (Normally Closed): A switch that will open at a specified point (temp, press, etc.).No circle indicates that the wire cannot be disconnected from the component.

PressureSymbol

TemperatureSymbol

LevelSymbol

FlowSymbol

Circuit BreakerSymbol

Reed Switch: A switch whose contacts are controlled by a magnet. A magnet closes the contacts of a normally open reed switch; it opens the contacts of a normally closed reed switch.

Sender: A component that is used with a temperature or pressure gauge. The sender measures the temperature or pressure. Its resistance changes to give an indication to the gauge of the temperature or pressure.

Relay (Magnetic Switch): A relay is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close the switch part of the relay.

Solenoid: A solenoid is an electrical component that is activated by electricity. It has a coil that makes an electromagnet when current flows through it. The electromagnet can open or close a valve or move a piece of metal that can do work.

Harness and Wire Symbols1 12 2

Sure-Seal connector: Typical representationof a Sure-Seal connector. The plug and receptacle contain both pins and sockets.

Deutsch connector: Typical representationof a Deutsch connector. The plug contains all sockets and the receptacle contains all pins.

Symbols

Symbols and DefinitionsFuse - A component in an electrical circuit that will open the circuit if too much current flows through it.

MAGNETIC LATCH SOLENOID - A magnetic latch solenoid is an electrical component that is activated by electricity and held latched by a permanent magnet. It has two coils (latch and unlatch)that make electromagnet when current flows through them. It also has an internal switch that places the latch coil circuit open at the time the coil latches.

Harness And Wire Electrical Schematic Symbols

Fuse(5 Amps)

5A

KE

NR

5711-0

1 V

OL

1 o

f 3

36

Pa

ge

, (D

ime

ns

ion

s:

48

in

ch

es

x 3

5 i

nc

he

s)

KENR5711-01September 2007

Volume 1 of 3: Cab

© 2007 Caterpillar, All Rights Reserved Printed in U.S.A.

D3K, D4K and D5K

Electrical SystemTrack-Type Tractor

D4K:MMM1-UP (XL)RRR1-UP (LGP)

D5K:WWW1-UP (XL)YYY1-UP (LGP)JLF1-UP (LGP)

D3K:FFF1-UP (XL)LLL1-UP (LGP)JTD1-UP (LGP)

1

32

25

A

9

23

4

33

68

22

27

3028

29

31

7

5

2

3

11

10

21

20

14

13

1917

12

16

18

15

PLATFORM WIRING - (P) HARNESS

CAB WIRING - (C) HARNESS, (FC) HARNESS, (R) HARNESS

B

Volume 1 - Component LocationComponent Schematic

LocationMachine Location

Control, HVAC I-12 23Control, Implement (LH) I-9 27Control, Implement (RH) G-9 28Control, Machine E-8 24Ground, Console A-14 5Ground, Frame B-8 26Ground, Platform B-8 26Ground, Roof C-15 25Handle, Implement Control (LH) G-9 29Handle, Implement Control (RH) I-9 30Handle, Winch/Ripper B-10 AHorn, Action Alarm F-9 BMotor, Front Wiper H-1 33Motor, Rear Wiper E-15 32Port, Power H-11 23Relay, Blower (High) I-11 AResistor, CAN A F-9 BSensor, Brake Pedal Deceleration E-9 BSwitch, 4th Valve C-10 ASwitch, 4th Valve Float B-11 ASwitch, A/C I-12 23Switch, Implement Lockout E-11 ASwitch, Keystart F-9 BSwitch, Lights C-11 ASwitch, Operator Presence F-11 31Switch, Parking Brake F-11 ASwitch, Service Brake E-9 BSwitch, Slow Engine Efficiency Reverse E-11 ASwitch, Throttle B-10 ASwitch, Winch Drive Away B-10 ASwitch, Winch Free Spool C-11 ASwitch, Wiper (Front) D-11 ASwitch, Wiper (Left) D-11 ASwitch, Wiper (Rear) D-11 ASwitch, Wiper (Right) D-11 AMachine locations are repeated for components located close together.A = Located inside of right console.B = Located inside of dash panel.

Volume 1 - Connector LocationConnector Number Schematic


CONN 1 G-15 1CONN 2 G-15 1CONN 3 B-14 2CONN 4 B-14 2CONN 5 H-14 3CONN 6 I-14 4CONN 7 I-14 4CONN 8 F-12 5CONN 9 H-12 6CONN 10 H-11 7CONN 11 I-11 8CONN 12 I-11 9CONN 13 D-9 10CONN 14 A-8 11CONN 15 G-7 2CONN 16 A-3 12CONN 17 B-3 13CONN 18 B-3 14CONN 19 C-3 14CONN 20 C-3 15CONN 21 C-3 15CONN 22 D-3 15CONN 23 D-3 16CONN 24 E-3 16CONN 25 F-3 17CONN 26 G-3 18CONN 27 H-3 19CONN 28 I-3 20CONN 29 I-3 21CONN 30 B-2 22

The connectors shown in this chart are for harness to harness connectors. Connectors that join a harness to a component are generally located at or near the component. See the Component Location Chart.

Wire DescriptionWire

Number Wire Color Description Wire Number Wire Color Description

Power Circuits Control Circuits (Continued)

102 BU Running Lamps E912 PU Lift Lever Neutral Postion Switch (N.O.)103 YL Auxiliary Circuit E913 YL Lift Lever Neutral Postion Switch (N.C.)105 RD Key Switch E918 GN Implement Lockout Switch (N.C.)106 WH Dome Lamp E965 BU Engine Speed / Timing Sensor B (-)108 RD Cab Radio F711 GN Engine CAN 1 (+)110 RD GPS Display F712 GY Engine CAN 1 (-)112 PU Main Power Relay Output F773 OR Governor Accelerate114 RD Forward Warning Horn F774 WH Governor Decelerate115 RD Machine Control F853 BR Travel Speed118 GY Front Wiper F868 OR Winch Cable Out Solenoid119 PK Rear Wiper F869 PK Winch Cable In Solenoid120 YL Left Wiper F870 BU Winch Freespool Solenoid122 BU Right Wiper F931 PK Parking Brake Solenoid Return124 GN HVAC Blower G434 BU All Wheel Drive Oil Temperature Sensor125 OR HVAC Control G985 PU Seat Switch126 PK Transmission Control H414 YL Warning Switch To Alarm127 RD Product Link H451 GN Water In Fuel Sensor129 BU Accessory Power Port H708 OR Implement Control Kickout Switch #1130 RD Auxiliary Circuit H710 PK Implement Control Lift Lever Position158 BR HVAC Condensor #1 H711 GN Implement Control Tilt Lever Position159 BU HVAC Condensor #2 H713 PK Implement Control Lift Solenoid180 RD Operator Seat H714 OR Implement Control Lower Solenoid184 BU Accugrade Power Module H777 OR Warning Lamp To Switch #1195 YL Product Link H779 GN Warning Lamp To Switch #3

Ground Circuits H801 PU Proportional Driver 1-4 Return (ECM 1)200 BK Main Chassis H802 GY Proportional Driver 5-8 Return (ECM 1)202 BK Transmission Control #1 J764 BR Switch / Sensor Return #1

Basic Machine Circuits J765 BU Switch / Sensor Return #2304 WH Starter Relay #1 Output J766 PU Switch / Sensor Return #3306 GN Key Switch To Starter Relay J807 BK Proportional Return #1307 OR Key Switch To Neutral Start Switch or Control J808 BK Proportional Return #2308 YL Main Power Relay Coil J809 BK Proportional Return #3309 GY Alternator Regulator J813 BK Proportional Return #4310 PU Start Aid Switch To Start Aid Solenoid J913 GN Ripper In Valve320 OR Horn Switch To Horn Relay J914 PU Ripper Lower Valve321 BR Backup Alarm Lamp / Travel Alarm J921 PK Ripper Lift Valve322 GY Forward Warning Horn J922 GY Ripper Out Valve375 BR Flamp Plug System Fuel Solenoid J943 GN Implement Mode Switch (N.O.)382 PK Start Aid Solenoid (+) J944 BU Implement Mode Switch (N.C.)383 GN Start Aid Solenoid (-) J946 OR Implement Manual Mode Switch (N.C.)

Monitoring Circuits J948 PK Ripper Lift / Lower403 GN Alternator 'R' Terminal - Engine #1 J992 YL Miscellaneous Switch #1430 BU Air Filter J993 PK Miscellaneous Switch #2447 PK Fuel Level Gage J994 GY Miscellaneous Switch #3450 YL Engine #1 Tachometer Sender (+) K757 YL Blade Rotation451 BR Engine #1 Tachometer Sender (-) K779 PU Alternator 'D' Terminal497 BU Sensor Power K943 OR Travel Left Solenoid - Front

Accessory Circuits K944 YL Travel Left Solenoid - Rear500 BR Wiper - Front (Park) K946 OR Travel Right Solenoid - Rear502 OR Wiper - Front (High) K947 YL Travel Right Solenoid - Front503 BR Wiper - Rear (Park) K960 PK Controller Data Link (+)505 BU Wiper - Rear (High) K961 GN Controller Data Link (-)506 PU Washer - Front L730 OR 5V Analog Sensor Supply507 WH Washer - Rear L731 BR Analog Sensor Return508 PU Radio Speaker - Left (+) L856 YL Blade Control CAN 1 (+)509 WH Radio Speaker - Left (-) L857 GN Blade Control CAN 1 (-)511 BR Radio Speaker - Right (+) L872 BU Blade Control Switched Power #1512 GN Radio Speaker - Right (-) L873 GY Blade Control Switched Power #2515 GY HVAC Blower Motor (High) M700 BR Indicator - Seated516 GN HVAC Blower Motor (Medium) M730 YL Governor Motor Sensor Signal517 BU HVAC Blower Motor (Low) M792 BU Charge Filter Bypass Switch521 YL Fan Speed Switch To A/C Pressure Switch M795 WH Wastegate Valve (+)522 WH A/C Clutch To Thermostat Switch M928 BU Right Tilt Valve523 BR Wiper - Left (Park) M929 WH Left Tilt Valve524 BU Wiper - Left (Low) N805 BU 4th Valve Switch526 YL Wiper - Right (Park) N809 OR Seer Sw527 GN Wiper - Right (Low) N812 GN Auxiliary ECM529 WH Washer - Left N821 GN 4th Valve Float Indicator530 OR Washer - Right N822 BR 4th Valve Float Indicator567 WH A/C Switch Jumper #1 N824 PK Seer Indicator579 BR HVAC Blower Motor #1 N825 PK Seer Sw589 GN A/C Pressure Switch To A/C Clutch N957 PK RXD - Comm #1

Lighting Circuits N958 PK RS232 Receive 2607 PK Flood Lamps - Front #1 N960 PK TXD - Comm 1608 GN Flood Lamps - Rear #1 N961 OR RS232 Transmit 2614 PU Tail / Position / Dash Lamps N964 BU DSR - Comm 1643 GN Display Intensity Increase N967 GY CTS - Comm 1647 GN Switch To Rear Flood Lamps Relay N970 YL DTR - Comm 1

Control Circuits N973 BR DCD - Comm 1709 OR Sensor Power #2 N976 PU RTS - Comm 1751 GN Transmission Shift Solenoid #1 or #3 N979 GN Signal Ground - Comm 1752 YL Transmission Shift Solenoid #2 P730 GN Winch Brake Solenoid769 BU Wheel Speed Sensor - Left P781 GY Grapple Winch Reel Out Slow Switch (N.C.)770 GN Wheel Speed Sensor - Right P782 PK Grapple Winch Reel Out Slow Switch (N.O.)833 GY Hydrostatic Right Motor Speed Sensor P783 WH Grapple Winch Reel Out Off Switch (N.C.)835 PU Hydrostatic Left Motor Speed Sensor P784 OR Grapple Winch Reel Out Fast Switch (N.O.)869 PU Hydrostatic Control Calibrate Switch P920 BR Secondary Engine Speed / Timing Sensor (-)892 BR CAT Data Link 3 (-) R981 YL Travel Speed Solenoid893 GN CAT Data Link 3 (+) R993 BR Analog Sensor Return915 GN Hydrostatic Control Pilot Override Valve R997 OR 5V Analog Sensor Power975 WH Autoshift Solenoid Return T744 WH Blade Control - Switched Power #1 Return994 GY Oil Pressure (Filtered) T745 YL Blade Control - Switched Power #2 Return995 BU Coolant Temperature T901 YL Machine Security System Exciter Coil (In)996 GN Engine Speed / Timing Sensor Power T902 PK Machine Security System Exciter Coil (Out)

A101 GN Blade Control #1 T951 BK Injector #1 (+)A106 YL Grade Control Beeper T952 BK Injector #2 (+)A287 BK Engine Control #2 T953 BK Injector #3 (+)A314 OR Park Brake Sw To XMSN Neutralizer Relay T954 BK Injector #4 (+)A315 WH Park Brake Sw To XMSN Neutralizer Relay T957 BK Injector #1 ReturnA499 BU Hydraulic Oil Pressure T958 BK Injector #2 ReturnA528 YL Electronic Water Valve Actuator T959 BK Injector #3 ReturnA755 PK Throttle Switch #1 T960 BK Injector #4 ReturnA756 BU Throttle Switch #2 T993 BR Analog Sensor ReturnA757 GY Throttle Switch #3 T997 OR 5V Analog Sensor PowerA758 BR Throttle Switch #4 U717 OR Auxiliary Valve 5 - Solenoid #1A958 WH Parking Brake Solenoid X731 BU Boost PressureC211 BK Waste Gate Valve X920 BR Injector #1 (+)C218 BK Grade Control Beeper X921 PK Injector #2 (+)C546 WH HVAC Blower Motor Medium / Low Relay X922 WH Injector #3 (+)C556 BU Relay To Condensor Motor #1 X923 OR Injector #4 (+)C557 OR Relay To Condensor Motor #2 X926 GY Injector #1 ReturnC558 BU Front Wiper Switch Jumper X927 YL Injector #2 ReturnC568 WH HVAC Blower Motor (MAX) X928 GN Injector #3 ReturnC703 BR Neutral Switch X929 BU Injector #4 ReturnC831 GN Winch Hydraulic Pressure Y758 PK Serial Data 2 TransmitC958 BU Motor Speed High / Low - Right Y934 WH Accugrade Increment / Decrement Sw (N.C.)C959 BR Motor Speed High / Low - Left Y946 BU Fuel Rail Pressure SignalC967 BU Inlet Air Temperature Y947 BR Analog Sensor ReturnC992 PU Service Brake Switch #1 Y948 BR Analog Sensor ReturnE752 YL Lightbar 1 RS232 TX Y950 YL Fuel Pump Solenoid (+)E753 WH Lightbar 1 RS232 RX Y951 PU Fuel Pump Solenoid Return

Related Electrical Service ManualsTitle Form Number

Machine Control: KENR6176

Engine Control: KENR5390

Component Identifiers (CID¹)Module Identifier (MID²)

CID Component0001 Injector Cylinder #10002 Injector Cylinder #20003 Injector Cylinder #30004 Injector Cylinder #40005 Injector Cylinder #50006 Injector Cylinder #6

0041 8 Volt DC Supply0091 Throttle Position Sensor0100 Engine Oil Level Sensor0110 Engine Coolant Temperature Sensor0168 Electrical System Voltage0172 Intake Manifold Air Temperature Sensor0174 Fuel Temperature Sensor0190 Engine Speed Sensor0247 SAE J1939 Data Link0248 CAT Data Link0253 Personality Module0261 Engine Timing Calibration0262 5 Volt Sensor DC Power Supply0266 Crank Without Injection Input0267 Remote Shutdown Input0268 Programmed Parameter Fault

0291 Engine Cooling Fan Solenoid

0296 Transmission Control

0342 Secondary Engine Speed Sensor

0444 Starter Motor Relay

0526 Turbo Wastegate Actuator

1603 Machine Control Module

1639 Machine Security System Module

1779 Fuel Rail Pressure Valve 1 Solenoid

1785 Inlet Manifold Pressure Sensor

1797 Fuel Rail Pressure Sensor

1834 Ignition Key Switch

2417 Ether Injection Control Solenoid

Machine Control System(MID No. 039)

CID Component0041 Sensor Power Supply (8 DCV)0070 Parking Brake Switch0091 Throttle Position Switch0096 Fuel Level Sensor0133 Transmission Pilot Pressure Solenoid0148 Hystat Drive Pressure Sensor0168 Electrical System Voltage0190 Engine Speed Sensor0247 J1939 Data Link0262 5 Volt Sensor DC Power Supply0268 Programmable Parameter0271 Action Alarm0298 Service Brake Pedal Switch0352 Lift Lever Position Sensor0358 Implement Pilot Pressure Supply0444 Starter Motor Relay0490 Hydraulic Lockout Switch0497 Tilt Right Solenoid0498 Tilt Left Solenoid0590 Engine Control Module0600 Hydraulic Oil Temp Sensor0681 Parking Brake Solenoid0811 Gauge Cluster #11078 Blade Control Handle Raise/Lower Position1079 Blade Control Handle Tilt Position Sensor1197 Blade Lower Solenoid1198 Blade Raise Solenoid1251 Alternator R-Terminal Signal1482 Sensor Power Supply (10 DCV)1558 Electronic Implement Control1699 Joystick Forward/Reverse Position Sensor1700 Joystick Left/Right Position Sensor1703 Left Drive Pump Forward Proportional1704 Left Drive Pump Reverse Proportional1705 Right Drive Pump Forward Proportional1706 Right Drive Pump Reverse Proportional1707 Left Drive Motor Solenoid1708 Right Drive Motor Solenoid1870 Blade Control Handle Thumb Rocker1884 Winch Spool In Solenoid1885 Winch Spool Out Solenoid1933 Blade Angle Left Solenoid1934 Blade Angle Right Solenoid1960 Ignition Key Reader2213 Operator In Seat Switch2143 Electronic Implement Control #32204 Auxiliary Lever #1 Position Sensor2205 Auxiliary Lever #2 Position Sensor2211 Auxiliary Valve #1 Port B Solenoid2212 Auxiliary Valve #1 Port A Solenoid2213 Auxiliary Valve #2 Port B Solenoid2214 Auxiliary Valve #2 Port A Solenoid2225 Hydraulic System Master ECM2268 Winch Free Spool Solenoid2305 Brake/Decelerator Pedal Position Sensor2438 Winch Free Spool Switch2440 Winch Brake Solenoid2441 Winch Motor Pressure Sensor2481 Winch Drive Away Switch2482 Winch Drive Away Solenoid2500 Powertrain Speed Range Control Position2532 Operator Gear Ratio Set/Recall Switch2679 Blade Shake Switch2685 Left Drive Motor Speed Sensor #12686 Left Drive Motor Speed Sensor #22687 Right Drive Motor Speed Sensor #12688 Right Drive Motor Speed Sensor #22754 Auxiliary #1 Switch2755 Blade Control Mode Switch2954 Unknown Electronic Implement Control3020 Auxiliary Valve #1 Float Switch3033 Fuel Efficient Reverse Switch

¹ The is a diagnostic code that indicates which circuit is faulty.² The MID is a diagnostic code that indicates which electronic control modulediagnosed the fault.

Failure Mode Identifiers (FMI)¹FMI No. Failure Description

Data valid but above normal operational range.1 Data valid but below normal operational range.2 Data erratic, intermittent, or incorrect.3 Voltage above normal or shorted high.4 Voltage below normal or shorted low.5 Current below normal or open circuit.6 Current above normal or grounded circuit.7 Mechanical system not responding properly.8 Abnormal frequency, pulse width, or period.9 Abnormal update.10 Abnormal rate of change.11 Failure mode not identifiable.12 Bad device or component.13 Out of calibration.14 Parameter failures.15 Parameter failures.16 Parameter not available.17 Module not responding.18 Sensor supply fault.19 Condition not met.20 Parameter failures.

¹The FMI is a diagnostic code that indicates what type of failure has occurred.

Volume 1 - Resistor SpecificationsPart No. Component Description Resistance (Ohms)¹134-2540 Resistor: CAN A (Dash) 120¹ At room temperature unless otherwise noted.

KE

NR

5711-0

1 V

OL

1 o

f 3

36

Pa

ge

, C

olo

r 2

, (D

ime

ns

ion

s:

48

in

ch

es

x 3

5 i

nc

he

s)

THIS SCHEMATIC IS FOR THE D3K, D4K & D5K TRACK-TYPE LOADER PART #: 239-5276-01Components are shown installed on a fully operable machine with the key and engine off and transmission shifter in neutral.

Refer to the appropriate Service Manual for Troubleshooting, Specifications and Systems Operations

ABBREV COLORRD REDWH WHITEOR ORANGEYL YELLOWPK PINKBK BLACKGY GRAYPU PURPLEBR BROWNGN GREENBU BLUE

COLOR ABBREVIATIONS

SYMBOL DESCRIPTION

BLADE, SPADE, RING OR SCREW TERMINAL

CIRCUIT CONNECTED

CIRCUIT NOT CONNECTED

ELECTRICAL CONNECTION TO MACHINE STRUCTURE

INTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT

CONNECTOR

ATCH WIRE, CABLE, COMPONENT

CIRCUIT CONNECTED

SPLICE

CIRCUIT GROUPING DESIGNATIONH#

A

B

C

D

E

F

G

H

I

A

B

C

D

E

F

G

H

I

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS OFF.WIRES THAT HAVE SYSTEM VOLTAGE WHEN THE KEY SWITCH IS ON.VOLTAGE CONVERTER OUTPUT CIRCUIT.STARTING CIRCUIT.GROUND CIRCUIT.STARTING AID CIRCUIT.

ENGINE CONTROL CIRCUIT.

RIPPER CONTROL CIRCUIT.

TRANSMISSION CONTROL CIRCUIT.MACHINE SECURITY CONTROL CIRCUIT.HEATER AND AIR CONDITIONER CIRCUIT.TURN SIGNAL/WIPER/WASHER CIRCUIT.

WIRE GROUP COLOR DESCRIPTIONS

RS-232 DATA LINK.

CAN DATA LINK D.

CAT DATA LINK.J1939(CAN) DATA LINK.

CAN DATA LINK B.

ACCUGRADE CONTROL CIRCUIT.

WINCH CONTROL CIRCUIT.

CONN 3

CONN 4

CONN 1

CONN 2

CONN 5

CONN 8

CONN 9

CONN 10

CONN 11

CONN 12

CONN 6

CONN 7

CONN 13

CONN 14

CONN 15

CONN 16CONN 30

CONN 17

CONN 18

CONN 19

CONN 20

CONN 21

CONN 22

CONN 23

CONN 24

CONN 25

CONN 26

CONN 27

CONN 28

CONN 29

DESCRIPTIONNOTE

ASSEMBLE TERMINALS TO DESIGNATED STUDNOTE A:

THE FOLLOWING WIRES ARE TO BE TWISTED TOGETHER (AT LEAST 1 TURN/25mm)

F711-GN AND F712-GY L856-YL AND L857-GN 892-BR AND 893-GNJ813-BK AND U717-OR K960-PK AND K961-GN 450-YL AND 451-BR H708-OR AND P730-GN J914-PU AND J913-GN J921-PK AND J922-GYF870-BU AND J809-WH

NOTE B:

INSERT PINS INTO RECEPTACLE AS. AFTER ASSEMBLY INTO DOORNOTE F:

FOR WINCH ATCH ONLY, ASSEMBLE CONNECTORS N-C1 AND N-C2 TO CONT A1 ECM 1. CONNECTOR N-C10 TO REMAIN ASSEMBLED TO CONNECTOR N-C8, AND JUMPER WIRE N970 TO REMAIN IN CONNECTOR N-C10.

NOTE G:

FOR WINCH WITH 4TH VALVE FUNCTION ATCH ASSEMBLE CONNECTORS N-C1 AND N-C2 TO CONT A1 ECM 1. DISASSEMBLE CONNECTOR N-C8 FROM N-C10. ASSEMBLE CONNECTORS N-C8 AND N-C9 TO CONT A1 ECM 2. [FOR FUTURE USE, TIE-WRAP CONNECTOR N-C10 TO HARNESS BREAKOUT.]

NOTE H:

FOR RIPPER ATCH ONLY, ASSEMBLE CONNECTORS N-C1 AND N-C9 TOCONT A1 ECM 1. CONNECTOR N-C10 TO REMAIN ASSEMBLED TOCONNECTOR N-C8, AND JUMPER WIRE N970 TO REMAIN IN CONNECTORN-C10.

NOTE J:

DOUBLE UPPERCASE LETTERS REPRESENT LOWER CASE LETTERS ON ACTUAL CONNECTORNOTE K:

IDENT PART NO. CHG LOCATION NOTE DESCRIPTIONHARNESS AS.

A 192-7805 00 SH 1 G-12 AIR SEATAC 276-4299 01 SH 3 D-2 HVACAE 249-9048 02 SH 2 I-7 AC COMPRESSORAH 249-9034 02 SH 3 B-11 ACCUGRADE AS400 BULKHEAD ATCHC 311-0292 00 SH 1 C-11 CONSOLE EROPSCL 311-0293 00 SH 2 G-8 CONSOLE OROPSE 288-0526 01 SH 2 H-1 ENGINEEG 238-2666 01 SH 2 H-3 INJECTOR CYLINDER JUMPEREH 249-9024 04 SH 2 C-13 ELECTRO-HYDRAULICEK 238-2666 01 SH 2 I-3 INJECTOR CYLINDER JUMPEREN 245-6040 06 SH 2 G-5 ENGINE AND HYSTATF 245-6037 04 SH 2 H-12 CASEFC 245-6044 03 SH 1 F-9 DASHFN 249-9065 02 SH 3 A-5 WINCH - CASE ATCHFP 249-9026 04 SH 2 C-7 FUSE PANELGA 311-0295 00 SH 3 H-11 ACCUGRADE DASH ATCHGC 249-9033 05 SH 3 I-13 ACCUGRADE CONSOLE ATCHGF 249-9031 01 SH 3 C-14 ACCUGRADE FRONT ATCHGH 249-9032 02 SH 3 B-13 ACCUGRADE HOOD ATCHGJ 311-0298 00 SH 3 F-7 ACCUGRADE GPS DISPLAY ATCHGP 249-9030 03 SH 3 A-15 ACCUGRADE (PM400) ATCHGR 311-0305 00 SH 3 I-15 ACCUGRADE ROOF ATCHGV 311-0297 00 SH 3 H-7 ACCUGRADE LASER DISPLAY ATCHGW 249-9035 02 SH 3 F-5 GATEWAY WORLDVIEW ATCHHN 269-7648 01 SH 2 H-5 HORNLA 269-7656 04 SH 1 H-10 LEFT ARMRESTLH 249-9049 02 SH 3 C-10 GR CONT LEFT BULKHEAD ATCHLW 249-9060 01 SH 3 I-1 LH DOORMR 249-9028 01 SH 3 G-1 MACHINE SECURITY SYSTEM ATCHN 269-7697 00 SH 3 D-8 WINCH - RIPPER ATCHP 311-0294 00 SH 1 H-7 PLATFORMPL 249-9069 03 SH 3 H-5 PRODUCT LINK ATCHRA 269-7657 02 SH 1 G-9 RIGHT ARMRESTRH 249-9050 02 SH 3 C-10 ACCUGRADE RIGHT BULKHEAD ATCHRW 249-9061 02 SH 3 H-1 RH DOORRL 245-6032 05 SH 2 B-12 ROOF - OROPSR 245-6043 05 SH 1 B-14 ROOF - EROPSW 185-4303 02 SH 3 F-1 A/C CONDENSER GPWN 269-7667 00 SH 2 I-5 WINCH PUMP ATCHY 249-9062 02 SH 2 I-15 WASHER PUMPS

WIRE AS.WH 249-9067 01 SH 2 H-15 HYD BYP SW ATCH

CABLE AS.AA 249-9072 03 SH 2 F-7 POS (STARTER TO ALT)CC 249-9019 04 SH 2 F-7 NEG (DISC SW TO GND)EE 269-7658 02 SH 2 G-7 POS (BAT. TO STARTER)FF 249-9017 05 SH 2 G-7 POS (BAT. TO ST TO JCT BLK)HH 249-9018 04 SH 2 G-7 NEG (BAT. TO DISC SW)

EROPS ROOF

CONN TO W-C1A/C CONDENSER HARN

[LOC SH 3 F-1]

EROPS CONSOLE

RIGHT ARM REST

608-R1 GN-18

608-R1 GN-18

158-R2 BR-12

158-R2 BR-12

608-R1 GN-18

509-R4 WH-18

508-R5 PU-18

508-R5 PU-18509-R4 WH-18

200-R12 BK-18

200-R12 BK-18

200-R12 BK-18

511-R7 BR-18

511-R7 BR-18

608-R13 GN-18

608-R13 GN-18

608-R13 GN-18

200-R15 BK-18

200-R15 BK-18

200-R15 BK-18

106-R3 WH-18

106-R3 WH-18

106-R3 WH-18

200-R16 BK-18

200-R16 BK-18

200-R16 BK-18

200-R17 BK-16

200-R17 BK-16

200-R17 BK-16500-R19 BR-16

500-R19 BR-16

500-R19 BR-16

502-R18 OR-16

502-R18 OR-16

502-R18 OR-16

118-R20 GY-16

118-R20 GY-16

118-R20 GY-16

503-R39 BR-16

503-R39 BR-16

505-R28 BU-16

505-R28 BU-16

119-R29 PK-16

119-R29 PK-16

200-R30 BK-18

200-R30 BK-18

200-R31 BK-16

200-R31 BK-16

607-R32 PK-18

607-R32 PK-18

607-R33 PK-18

607-R33 PK-18

512-R38 GN-18

200-R35 BK-18

200-R35 BK-18

200-R37 BK-12

200-R37 BK-12

159-R34 BU-12

159-R34 BU-12

200-R36 BK-12

200-R36 BK-12

F853-LA12 BR-18

C703-LA11 BR-18

320-LA7 OR-16

R981-LA5 YL-18

F773-LA3 OR-18

F774-LA6 WH-18

H711-RA19 GN-18

H711-RA19 GN-18

H710-RA20 PK-18

H710-RA20 PK-18

709-LA9 OR-18J764-LA10 BR-18

J764-RA18 BR-18

J764-RA18 BR-18

J764-RA7 BR-18

J764-RA7 BR-18

J764-RA21 BR-16

709-RA17 OR-18

709-RA17 OR-18

709-RA6 OR-18709-RA6 OR-18

709-RA22 OR-18K757-RA8 YL-18

K757-RA8 YL-18

J944-RA12 BU-18

J944-RA12 BU-18

J946-RA11 OR-18

J946-RA11 OR-18

J943-RA5 GN-18

J943-RA5 GN-18

Y934-RA10 WH-18

Y934-RA10 WH-18

200-R48 BK-14

200-R48 BK-14

709-FC1 OR-18J764-FC2 BR-18M730-FC3 YL-18

202-FC4 BK-18F931-FC5 PK-18C992-FC6 PU-18

105-FC8 RD-18202-FC9 BK-18

F711-FC10 GN-18F712-FC11 GY-18

308-FC13 YL-18

202-FC14 BK-18

H414-FC7 YL-18

H414-FC7 YL-18202-FC15 BK-18

F711-FC16 GN-18

F711-FC16 GN-18

F712-FC17 GY-18

F712-FC17 GY-18

F711-FC18 GN-18

F711-FC18 GN-18

F711-FC10 GN-18

F712-FC11 GY-18

202-FC15 BK-18

105-FC8 RD-18

202-FC9 BK-18

308-FC13 YL-18

202-FC14 BK-18

F712-FC19 GY-18

F712-FC19 GY-18

F931-FC5 PK-18

C992-FC6 PU-18709-FC1 OR-18

J764-FC2 BR-18M730-FC3 YL-18

202-FC20 BK-18

202-FC20 BK-18

202-FC4 BK-18

709-FC1 OR-18C992-FC6 PU-18

F931-FC5 PK-18

M730-FC3 YL-18

DASH

200-C28 BK-18

614-C5 PU-18

200-C28 BK-18

202-C29 BK-18

202-C29 BK-18

320-C30 OR-16

320-C30 OR-16

A314-C33 OR-18

200-C8 BK-18

200-C6 BK-16

516-C2 GN-14

515-C1 GY-12

200-C20 BK-18

517-C18 BU-14

614-C13 PU-18

200-C15 BK-18567-C7 WH-18

200-C17 BK-18

567-C7 WH-18

200-C17 BK-18200-C15 BK-18

614-C13 PU-18

517-C18 BU-14

517-C18 BU-14

200-C8 BK-18

200-C6 BK-16

614-C5 PU-18

516-C2 GN-14

516-C2 GN-14

200-C20 BK-18

709-C31 OR-18

709-C31 OR-18

F773-C39 OR-18

A315-C34 WH-18

F774-C40 WH-18

C703-C35 BR-18

F853-C41 BR-18

H710-C42 PK-18H711-C43 GN-18

J943-C46 GN-18

J764-C45 BR-18

J764-C45 BR-18

J944-C47 BU-18

Y934-C53 WH-18

R981-C57 YL-18

J946-C49 OR-18

202-C65 BK-18

202-C65 BK-18

M730-C72 YL-18J764-C67 BR-18

J764-C67 BR-18

709-C76 OR-18C992-C70 PU-18

515-C1 GY-12

122-C54 BU-18

122-C54 BU-18

122-C55 BU-18

122-C55 BU-18122-C60 BU-16

614-C61 PU-18

614-C61 PU-18

200-C78 BK-18

200-C78 BK-18

530-C63 OR-18

119-C81 PK-16

119-C81 PK-16

119-C80 PK-16

119-C80 PK-16

119-C74 PK-16

119-C74 PK-16

505-C75 BU-16

505-C75 BU-16

200-C77 BK-12

200-C77 BK-12

200-C79 BK-18

200-C79 BK-18

709-C76 OR-18

614-C82 PU-18

614-C82 PU-18

503-C83 BR-16

503-C83 BR-16

507-C84 WH-18

200-C86 BK-18

200-C86 BK-18

524-C87 BU-16

120-C88 YL-18

120-C88 YL-18

120-C89 YL-16

120-C89 YL-16

614-C90 PU-18

614-C90 PU-18

523-C91 BR-16

523-C91 BR-16

529-C92 WH-18

530-C63 OR-18

507-C84 WH-18

529-C92 WH-18

124-C93 GN-14124-C94 GN-14

200-C85 BK-18

200-C85 BK-18

614-C96 PU-18

614-C96 PU-18

502-C97 OR-16

502-C97 OR-16

118-C99 GY-16

118-C99 GY-16

118-C100 GY-16

118-C100 GY-16

308-C103 YL-18

506-C106 PU-18

506-C106 PU-18

307-C107 OR-18

307-C107 OR-18

200-C109 BK-16

120-C111 YL-16

120-C112 YL-16

118-C113 GY-16

118-C113 GY-16

512-R38 GN-18

503-R39 BR-16505-R28 BU-16

119-R29 PK-16118-R20 GY-16

200-C118 BK-18

607-R51 PK-14

607-R51 PK-14

608-R52 GN-14

608-R52 GN-14

614-C21 PU-18

A755-C126 PK-18A755-C126 PK-18A756-C127 BU-18A756-C127 BU-18A757-C128 GY-18A757-C128 GY-18A758-C129 BR-18A758-C129 BR-18

202-C130 BK-18

202-C130 BK-18

202-C130 BK-18

P783-C131 WH-18P784-C132 OR-18

202-C133 BK-18

202-C133 BK-18

202-C134 BK-18

202-C134 BK-18

P781-C135 GY-18P782-C136 PK-18

202-C146 BK-16

202-C146 BK-16

503-C83 BR-16

159-C144 BU-14159-C145 BU-14

500-C148 BR-16

500-C148 BR-16

500-C148 BR-16

106-R40 WH-18

106-R40 WH-18106-R41 WH-18

106-R41 WH-18

200-R42 BK-18

108-R43 RD-18

108-R43 RD-18

108-R43 RD-18

512-R38 GN-18511-R7 BR-18

508-R5 PU-18509-R4 WH-18

509-R4 WH-18508-R5 PU-18200-R42 BK-18

106-R40 WH-18108-R43 RD-18

511-R7 BR-18512-R38 GN-18

521-R44 YL-16

521-R44 YL-16

521-R44 YL-16

PLATFORM

647-C22 GN-16

200-C118 BK-18

F931-C114 PK-18

EROPS CONSOLE

607-C121 PK-14608-C122 GN-14

106-C139 WH-18108-C149 RD-18

308-C150 YL-18

500-R19 BR-16 500-C148 BR-16

503-C83 BR-16

202-C146 BK-16

200-C77 BK-12

J764-C153 BR-18

J764-C154 BR-18

J764-C154 BR-18

J764-C154 BR-18

709-C155 OR-18

709-C156 OR-18

709-C156 OR-18

709-C156 OR-18

J948-C157 PK-18

J948-C157 PK-18

200-C119 BK-16

502-R18 OR-16

122-C56 BU-16

122-C56 BU-16

120-C112 YL-16

523-C91 BR-16200-C125 BK-16

200-C125 BK-16

106-C139 WH-18

106-C139 WH-18

106-C139 WH-18

106-C139 WH-18

159-C145 BU-14

159-C145 BU-14

159-C145 BU-14

159-C145 BU-14

159-C144 BU-14

159-C144 BU-14

159-C144 BU-14

159-C144 BU-14

CONN TO FP-C10FUSE PANEL HARN[LOC SH 2 B-7]

105-FC21 RD-18

105-FC21 RD-18

105-FC22 RD-18

105-FC22 RD-18

307-FC23 OR-18

307-FC23 OR-18

307-FC23 OR-18

308-FC24 YL-18

308-FC25 YL-18

308-FC25 YL-18

308-FC24 YL-18

308-FC27 YL-18

308-FC27 YL-18

202-FC28 BK-18

202-FC28 BK-18

F711-FC29 GN-18

F711-FC29 GN-18

F712-FC30 GY-18

F712-FC30 GY-18

200-C69 BK-14

F711-C115 GN-18F712-C116 GY-18

308-C103 YL-18

158-R61 BR-14

158-R61 BR-14

158-R62 BR-14

158-R62 BR-14

159-R64 BU-14

159-R64 BU-14

159-R63 BU-14

159-R63 BU-14

202-C73 BK-18

105-C24 RD-18

105-C24 RD-18

105-C24 RD-18

200-C27 BK-18

200-C27 BK-18

200-C27 BK-18

108-C149 RD-18

108-C149 RD-18

108-C149 RD-18

108-C149 RD-18

506-C106 PU-18

506-C106 PU-18

507-C84 WH-18

507-C84 WH-18

529-C92 WH-18

529-C92 WH-18

530-C63 OR-18

530-C63 OR-18

647-C22 GN-16

647-C22 GN-16

118-C32 GY-16

118-C32 GY-16

118-C32 GY-16119-C59 PK-16

119-C59 PK-16

119-C59 PK-16

120-C111 YL-16

120-C111 YL-16

122-C60 BU-16

122-C60 BU-16

129-C19 BU-16

129-C19 BU-16

180-C62 GN-14

180-C62 GN-14

180-C62 GN-14

180-C62 GN-14

308-C150 YL-18

308-C150 YL-18

103-C152 YL-14

103-C152 YL-14

158-C14 BR-14

158-C14 BR-14

158-C14 BR-14

158-C14 BR-14

158-C14 BR-14

124-C93 GN-14

124-C93 GN-14

124-C94 GN-14

124-C94 GN-14

308-C71 YL-16

202-RA23 BK-18

607-C121 PK-14

607-C121 PK-14

607-C121 PK-14

607-C121 PK-14

608-C122 GN-14

608-C122 GN-14

608-C122 GN-14

608-C122 GN-14

516-C2 GN-14

517-C18 BU-14

647-C22 GN-16614-C21 PU-18

EROPS ROOF

CONN TO GC-C1ACCUGRADE CSL HARN[LOC SH 3 H-13]

195-C105 YL-18

195-C105 YL-18

195-C117 YL-18

195-C117 YL-18

200-C124 BK-16

H777-C137 OR-18H779-C104 GN-18

515-C1 GY-12

515-C1 GY-12

200-C95 BK-10

103-C152 YL-14

320-C30 OR-16

320-C30 OR-16

110-C98 RD-16

110-C98 RD-16

110-C98 RD-16

110-C98 RD-16

110-C98 RD-16

184-C108 BU-14

184-C108 BU-14

184-C108 BU-14

892-C110 BR-18893-C143 GN-18

K961-C158 GN-18

L857-C159 GN-18

T744-C160 WH-14

K960-C161 PK-18

200-C163 BK-16

L856-C164 YL-18

105-C24 RD-18

M700-C165 BR-18G985-C166 PU-18

614-C167 PU-18

614-C167 PU-18

522-C168 WH-16

K757-C50 YL-18

502-C48 OR-18

502-C48 OR-18

614-C169 PU-18

524-C52 BU-16

524-C52 BU-16

505-C64 BU-18

505-C64 BU-18

527-C120 GN-18

527-C120 GN-18

200-C170 BK-18

200-C170 BK-18

200-C171 BK-18

200-C171 BK-18

200-C172 BK-18

200-C172 BK-18

526-C58 YL-16

CONN TO EN-C12ENGINE HARN

[LOC SH 2 H-7]

614-C173 PU-18

614-C173 PU-18

614-C174 PU-18

614-C174 PU-18

200-C175 BK-18

200-C175 BK-18

200-C176 BK-18

200-C176 BK-18

195-C177 YL-18

308-P1 YL-16

P730-P3 GN-18

202-P12 BK-18

J807-P7 BK-18

J807-P7 BK-18

F869-P8 PK-18

F869-P8 PK-18F868-P9 OR-18

J808-P10 BK-18

J808-P10 BK-18

709-P17 OR-16

K960-P18 PK-18

K960-P18 PK-18

K961-P19 GN-18

K961-P19 GN-18

K961-P20 GN-18

K961-P20 GN-18

K960-P23 PK-18

K960-P23 PK-18

403-P25 GN-18

403-P25 GN-18

893-P34 GN-18 893-P34 GN-18

893-P34 GN-18

893-P35 GN-18

893-P35 GN-18

893-P36 GN-18893-P36 GN-18

892-P37 BR-18

892-P37 BR-18

892-P38 BR-18

892-P38 BR-18

892-P39 BR-18

892-P39 BR-18

892-P39 BR-18

200-P40 BK-14

200-P40 BK-14

200-P40 BK-14

202-P41 BK-10

202-P41 BK-10

202-P41 BK-10

306-P42 GN-18

306-P42 GN-18

306-P42 GN-18

306-P42 GN-18

403-P44 GN-18

403-P44 GN-18

403-P44 GN-18

450-P45 YL-18

450-P45 YL-18

450-P45 YL-18

450-P45 YL-18

451-P46 BR-18

451-P46 BR-18

451-P46 BR-18

451-P46 BR-18

WINCH-RIPPERLEVER (ATCH)

521-C180 YL-16

521-C180 YL-16

521-C181 YL-16

521-P49 YL-16

522-P50 WH-16

522-P50 WH-16

915-P51 GN-18

915-P51 GN-18

915-P51 GN-18

915-P51 GN-18

A958-P52 WH-18

A958-P52 WH-18

A958-P52 WH-18

F711-P54 GN-18

F711-P54 GN-18

F712-P55 GY-18

F712-P55 GY-18

F712-P55 GY-18

F712-P57 GY-18

F712-P57 GY-18

F711-P56 GN-18

F711-P56 GN-18

F711-P14 GN-18

F711-P14 GN-18

F712-P72 GY-18

F712-P72 GY-18

H801-P58 PU-18

H801-P58 PU-18

H801-P58 PU-18

K944-P60 YL-18K944-P60 YL-18

K944-P60 YL-18

K944-P60 YL-18

K943-P59 OR-18K943-P59 OR-18

K943-P59 OR-18

K943-P59 OR-18

K947-P62 YL-18K947-P62 YL-18

K947-P62 YL-18

K947-P62 YL-18

K946-P61 OR-18K946-P61 OR-18

K946-P61 OR-18

K946-P61 OR-18

N979-P73 GN-18N960-P77 OR-18N957-P80 PK-18

N957-P80 PK-18

126-P82 PK-14

126-P82 PK-14

126-P84 PK-14

126-P84 PK-14

126-P84 PK-14

126-P85 PK-14

126-P85 PK-14

126-P85 PK-14

126-P86 PK-14

126-P86 PK-14

126-P86 PK-14

126-P87 PK-14

126-P87 PK-14

126-P87 PK-14

R997-P88 OR-18

R997-P88 OR-18

R993-P89 BR-18

A499-P90 BU-18

A499-P90 BU-18

202-P91 BK-14

202-P91 BK-14

202-P91 BK-14202-P92 BK-14

202-P92 BK-14

202-P92 BK-14

202-P93 BK-14

202-P93 BK-14

202-P93 BK-14

321-P94 BR-18

J765-P95 BU-18

C959-P97 BR-18C959-P97 BR-18 C958-P98 BU-18C958-P98 BU-18H802-P99 GY-18

H802-P99 GY-18

R993-P100 BR-18

R993-P100 BR-18

R993-P101 BR-18

447-P102 PK-18

447-P102 PK-18

709-P103 OR-18

709-P103 OR-18

709-P126 OR-18

709-P126 OR-18

J764-P104 BR-18

J764-P104 BR-18

M730-P105 YL-18C703-P106 BR-18F853-P127 BR-18

R981-P109 YL-18

F773-P108 OR-18

F774-P110 WH-18

J943-P83 GN-18

G434-P125 BU-18

A314-P111 OR-18A315-P112 WH-18

J766-P114 PU-18

J766-P114 PU-18

497-P113 BU-18

497-P113 BU-18

P781-P118 GY-18P782-P119 PK-18

H779-P115 GN-18

P783-P116 WH-18P784-P117 OR-18

307-P120 OR-18

J992-C186 YL-18J993-C187 PK-18

202-C188 BK-18

202-C188 BK-18

202-C189 BK-18

202-C189 BK-18

200-C190 BK-18

200-C190 BK-18

200-C191 BK-18

200-C191 BK-18

614-C192 PU-18

614-C192 PU-18

614-C193 PU-18

614-C193 PU-18

F711-P134 GN-18

F711-P134 GN-18

F712-P135 GY-18

F712-P135 GY-18

769-P136 BU-18

J992-P137 YL-18J993-P138 PK-18

835-P139 PU-18

835-P139 PU-18

770-P140 GN-18

770-P140 GN-18

833-P141 GY-18

833-P141 GY-18

M792-P142 BU-18

M792-P142 BU-18

Y934-P144 WH-18

K757-P145 YL-18

J946-P146 OR-18J944-P147 BU-18

H711-P149 GN-18H710-P148 PK-18

J764-P151 BR-18

J948-P152 PK-18

E912-P202 PU-18E913-P153 YL-18

A755-P154 PK-18

A756-P155 BU-18A757-P156 GY-18A758-P157 BR-18

H777-P158 OR-18

H708-P159 OR-18

F931-P162 PK-18

C992-P163 PU-18

J765-P164 BU-18

J765-P164 BU-18J765-P165 BU-18

J765-P165 BU-18

J765-P165 BU-18

H708-P159 OR-18

H708-P159 OR-18

H802-P166 GY-18

H802-P166 GY-18

H708-P168 OR-18

H708-P168 OR-18

H708-P2 OR-18

F711-P171 GN-18

F711-P171 GN-18

F711-P171 GN-18

F712-P172 GY-18

F712-P172 GY-18

F712-P172 GY-18

506-P173 PU-18507-P174 WH-18

529-P175 WH-18

530-P201 OR-18

A101-P178 GN-14

195-P179 YL-14

195-P179 YL-14

195-P180 YL-14

195-P180 YL-14

195-P181 YL-18

195-P181 YL-18

892-P182 BR-18

892-P182 BR-18

893-P183 GN-18

L856-P185 YL-18

L856-P185 YL-18

L857-P186 GN-18

N970-P187 YL-18N973-P188 BR-18

N973-P188 BR-18

T744-P189 WH-14

127-P193 RD-18

127-P193 RD-18

127-P194 RD-14

127-P194 RD-14

T745-P195 YL-14

T745-P195 YL-14

T745-P195 YL-14

200-P197 BK-14

200-P197 BK-14

T744-P189 WH-14

T744-P189 WH-14T744-P198 WH-14

T744-P198 WH-14

L872-P199 BU-14

L873-P200 GY-14

L873-P200 GY-14

L873-P200 GY-14

502-C194 OR-16

502-C194 OR-16

505-C195 BU-16

505-C195 BU-16

524-C87 BU-16524-C196 BU-16

524-C196 BU-16

527-C51 GN-16

527-C51 GN-16

527-C197 GN-16

200-P203 BK-18

200-P203 BK-18

195-P204 YL-18

195-P204 YL-18

403-P205 GN-18

403-P205 GN-18

892-P206 BR-18

892-P206 BR-18

893-P207 GN-18

893-P207 GN-18

F711-P208 GN-18

F711-P208 GN-18

F712-P209 GY-18

F712-P209 GY-18

F712-P209 GY-18

T744-P210 WH-14

T744-P210 WH-14

T744-P210 WH-14

K960-P211 PK-18

K960-P211 PK-18

K960-P211 PK-18

K961-P212 GN-18

K961-P212 GN-18

K961-P212 GN-18

521-C4 YL-18

521-C4 YL-18

892-P43 BR-18

892-P53 BR-18

893-P96 GN-18

893-P190 GN-18

F711-FC31 GN-18

F712-FC32 GY-18

F712-P220 GY-18

G985-P16 PU-18M700-P71 BR-18

J764-FC2 BR-18

195-P11 YL-16

K961-P20 GN-18

K960-P23 PK-18

A958-P52 WH-18

F711-P14 GN-18

F712-P72 GY-18

H801-P58 PU-18

K944-P60 YL-18K943-P59 OR-18

K947-P62 YL-18K946-P61 OR-18

H802-P99 GY-18

R993-P100 BR-18

R993-P101 BR-18

709-P126 OR-18

J764-P104 BR-18

F711-P134 GN-18

F712-P135 GY-18

J765-P164 BU-18

H708-P168 OR-18

403-P25 GN-18

893-P35 GN-18893-P36 GN-18

892-P37 BR-18892-P38 BR-18

306-P42 GN-18

450-P45 YL-18451-P46 BR-18

915-P51 GN-18

A958-P52 WH-18

F711-P54 GN-18

126-P82 PK-14

195-P179 YL-14195-P180 YL-14

127-P193 RD-18127-P194 RD-14

200-P197 BK-14200-P203 BK-18

195-P204 YL-18

403-P205 GN-18

892-P206 BR-18

893-P207 GN-18

F711-P208 GN-18

CONN TO RW-C1RH WIPER HARN[LOC SH 3 H-2]

CONN TO MR-C1MSS HARNESS

[LOC SH 3 G-3]

526-C58 YL-16

526-C58 YL-16

195-P11 YL-16

195-P11 YL-16

202-P12 BK-18

202-P12 BK-18

CONN TO N-C6WINCH HARNESS[LOC SH 3 D-8]

CONN TO N-C5WINCH HARNESS[LOC SH 3 D-8]

P730-P3 GN-18

P730-P3 GN-18

P730-P3 GN-18

709-P17 OR-16

709-P17 OR-16

F868-P9 OR-18

F868-P9 OR-18F869-P8 PK-18J807-P7 BK-18

J808-P10 BK-18

H708-P2 OR-18

H708-P2 OR-18

H801-P58 PU-18

200-P176 BK-18

200-P176 BK-18

200-P176 BK-18

CONNS TO F-C1CASE HARNESS

[LOC SH 2 H-12]

321-P94 BR-18

321-P94 BR-18

321-P94 BR-18

321-P94 BR-18

447-P102 PK-18

497-P113 BU-18

497-P113 BU-18

497-P113 BU-18

447-P102 PK-18

447-P102 PK-18

769-P136 BU-18

769-P136 BU-18 769-P136 BU-18

769-P136 BU-18

G434-P125 BU-18

770-P140 GN-18833-P141 GY-18835-P139 PU-18

C958-P98 BU-18C959-P97 BR-18

G434-P125 BU-18

H802-P166 GY-18

J765-P95 BU-18

J766-P114 PU-18

M792-P142 BU-18

770-P140 GN-18833-P141 GY-18835-P139 PU-18

C958-P98 BU-18C959-P97 BR-18

G434-P125 BU-18

J765-P95 BU-18

J766-P114 PU-18

M792-P142 BU-18

R993-P101 BR-18

770-P140 GN-18833-P141 GY-18835-P139 PU-18

C958-P98 BU-18C959-P97 BR-18

G434-P125 BU-18

J766-P114 PU-18

M792-P142 BU-18

521-P49 YL-16

L857-P186 GN-18

N970-P187 YL-18

L857-P186 GN-18

522-P50 WH-16

521-P49 YL-16

L856-P185 YL-18

L857-P186 GN-18L856-P185 YL-18

J764-P151 BR-18

893-P183 GN-18

522-P50 WH-16

521-P49 YL-16

P730-P3 GN-18

T744-P198 WH-14

L857-P186 GN-18

L856-P185 YL-18

K961-P19 GN-18

K960-P18 PK-18

J764-P151 BR-18

F712-P57 GY-18

F711-P56 GN-18

892-P182 BR-18

893-P183 GN-18

709-P103 OR-18

522-P50 WH-16

521-P49 YL-16

195-P181 YL-18

127-P192 RD-18

195-C177 YL-18

195-C177 YL-18

F711-P21 GN-18

F711-P21 GN-18

F711-P21 GN-18

F711-P218 GN-18

F712-P22 GY-18

F712-P22 GY-18

F712-P22 GY-18

307-C107 OR-18

307-C107 OR-18

308-C71 YL-16

308-C71 YL-16

521-C181 YL-16

521-C181 YL-16

522-C168 WH-16

522-C168 WH-16

522-C168 WH-16

522-C168 WH-16

709-C155 OR-18

709-C155 OR-18

892-C110 BR-18

892-C110 BR-18

892-C110 BR-18

892-C110 BR-18

893-C143 GN-18

893-C143 GN-18

893-C143 GN-18

893-C143 GN-18

A314-C33 OR-18

A314-C33 OR-18

A314-C33 OR-18

A315-C34 WH-18

A315-C34 WH-18

A315-C34 WH-18

A755-C126 PK-18

A755-C126 PK-18

A755-C126 PK-18

A756-C127 BU-18

A756-C127 BU-18

A756-C127 BU-18

A758-C129 BR-18

A758-C129 BR-18

A758-C129 BR-18

A757-C128 GY-18

A757-C128 GY-18

A757-C128 GY-18

C703-C35 BR-18

C703-C35 BR-18

C703-C35 BR-18

C992-C70 PU-18

C992-C70 PU-18

C992-C70 PU-18

E912-C36 PU-18

E912-C36 PU-18

E912-C36 PU-18

E913-C37 YL-18

E913-C37 YL-18

E913-C37 YL-18

F711-C115 GN-18

F711-C115 GN-18

F711-C115 GN-18

F712-C116 GY-18

F712-C116 GY-18

F712-C116 GY-18

F773-C39 OR-18

F773-C39 OR-18

F773-C39 OR-18

F774-C40 WH-18

F774-C40 WH-18

F774-C40 WH-18

F853-C41 BR-18

F853-C41 BR-18

F853-C41 BR-18

F931-C114 PK-18

F931-C114 PK-18

F931-C114 PK-18

H710-C42 PK-18

H710-C42 PK-18

H710-C42 PK-18

H711-C43 GN-18

H711-C43 GN-18

H711-C43 GN-18

H777-C137 OR-18

H777-C137 OR-18

H777-C137 OR-18

H779-C104 GN-18

H779-C104 GN-18

H779-C104 GN-18

G985-C166 PU-18

G985-C166 PU-18

G985-C166 PU-18

J764-C153 BR-18

J764-C153 BR-18

J943-C46 GN-18

J943-C46 GN-18

J943-C46 GN-18

J944-C47 BU-18

J944-C47 BU-18

J944-C47 BU-18

J946-C49 OR-18

J946-C49 OR-18

J946-C49 OR-18

J948-C157 PK-18

J948-C157 PK-18

J948-C157 PK-18

J992-C186 YL-18

J992-C186 YL-18

J992-C186 YL-18

J993-C187 PK-18

J993-C187 PK-18

J993-C187 PK-18

K757-C50 YL-18

K757-C50 YL-18

K757-C50 YL-18

M700-C165 BR-18

M700-C165 BR-18

M700-C165 BR-18

K960-C161 PK-18

K960-C161 PK-18

K960-C161 PK-18

K960-C161 PK-18

K961-C158 GN-18

K961-C158 GN-18

K961-C158 GN-18

K961-C158 GN-18

200-C119 BK-16

527-C197 GN-16

L856-C164 YL-18

L856-C164 YL-18

L856-C164 YL-18

L856-C164 YL-18

L857-C159 GN-18

L857-C159 GN-18

L857-C159 GN-18

L857-C159 GN-18

M730-C72 YL-18

M730-C72 YL-18

M730-C72 YL-18

P781-C135 GY-18

P781-C135 GY-18

P781-C135 GY-18

P782-C136 PK-18

P782-C136 PK-18

P782-C136 PK-18

P783-C131 WH-18

P783-C131 WH-18

P783-C131 WH-18

P784-C132 OR-18

P784-C132 OR-18

P784-C132 OR-18

R981-C57 YL-18

R981-C57 YL-18

R981-C57 YL-18

T744-C160 WH-14

T744-C160 WH-14

T744-C160 WH-14

T744-C160 WH-14

Y934-C53 WH-18

Y934-C53 WH-18

Y934-C53 WH-18 Y934-P144 WH-18

307-P120 OR-18

307-P120 OR-18

308-P1 YL-16

308-P1 YL-16

A314-P111 OR-18

A314-P111 OR-18

A315-P112 WH-18

A315-P112 WH-18

A755-P154 PK-18

A755-P154 PK-18

A756-P155 BU-18

A756-P155 BU-18

A758-P157 BR-18

A758-P157 BR-18

A757-P156 GY-18

A757-P156 GY-18

C703-P106 BR-18

C703-P106 BR-18

C992-P163 PU-18

C992-P163 PU-18

E912-P202 PU-18

E912-P202 PU-18

E913-P153 YL-18

E913-P153 YL-18

F773-P108 OR-18

F773-P108 OR-18

F774-P110 WH-18

F774-P110 WH-18

F853-P127 BR-18

F853-P127 BR-18

F931-P162 PK-18

F931-P162 PK-18

G985-P16 PU-18

G985-P16 PU-18

H710-P148 PK-18

H710-P148 PK-18

H711-P149 GN-18

H711-P149 GN-18

H777-P158 OR-18

H777-P158 OR-18

H779-P115 GN-18

H779-P115 GN-18

J943-P83 GN-18

J944-P147 BU-18

J944-P147 BU-18

J946-P146 OR-18

J946-P146 OR-18

J948-P152 PK-18

J948-P152 PK-18

J992-P137 YL-18

J992-P137 YL-18

J993-P138 PK-18

J993-P138 PK-18

K757-P145 YL-18

K757-P145 YL-18

M700-P71 BR-18

M700-P71 BR-18

M730-P105 YL-18

M730-P105 YL-18

P781-P118 GY-18

P781-P118 GY-18

P782-P119 PK-18

P782-P119 PK-18

P783-P116 WH-18

P783-P116 WH-18

P784-P117 OR-18

P784-P117 OR-18

R981-P109 YL-18

R981-P109 YL-18

506-P173 PU-18

506-P173 PU-18

507-P174 WH-18

507-P174 WH-18

529-P175 WH-18

529-P175 WH-18

530-P201 OR-18

530-P201 OR-18

200-R42 BK-18

200-R14 BK-10

200-R14 BK-10

200-R6 BK-10

200-R6 BK-10

CONN TO GW-C1PROD LINK 321SR HARN

[LOC SH 3 F-5]


[LOC SH 3 F-5]

CONN TO PL-C4PROD LINK 121SR HARN

[LOC SH 3 H-5]

202-P32 BK-14

202-P32 BK-14

202-P32 BK-14

CONN TO W-C6A/C CONDENSER HARN

[LOC SH 3 F-1]

LEFT ARM REST

200-C69 BK-14

202-C73 BK-18

202-RA23 BK-18709-RA22 OR-18H710-RA20 PK-18H711-RA19 GN-18J764-RA21 BR-16J943-RA5 GN-18J944-RA12 BU-18J946-RA11 OR-18K757-RA8 YL-18Y934-RA10 WH-18

709-LA1 OR-18J764-LA2 BR-18

709-LA1 OR-18

J764-LA2 BR-18

F773-LA3 OR-18

R981-LA5 YL-18

F774-LA6 WH-18

320-LA7 OR-16

709-LA9 OR-18

J764-LA10 BR-18

C703-LA11 BR-18

F853-LA12 BR-18

202-LA19 BK-18

202-LA19 BK-18320-LA7 OR-16

709-LA20 OR-18

709-LA20 OR-18C703-LA11 BR-18F773-LA3 OR-18F774-LA6 WH-18F853-LA12 BR-18

J764-LA21 BR-18J764-LA21 BR-18R981-LA5 YL-18

A314-C33 OR-18

709-C31 OR-18

614-C167 PU-18

320-C30 OR-16

202-C29 BK-18

200-C28 BK-18

A315-C34 WH-18

C703-C35 BR-18F773-C39 OR-18F774-C40 WH-18F853-C41 BR-18

J764-C45 BR-18

R981-C57 YL-18

E912-C36 PU-18E913-C37 YL-18

H710-C42 PK-18H711-C43 GN-18

J943-C46 GN-18J944-C47 BU-18J946-C49 OR-18K757-C50 YL-18

Y934-C53 WH-18

200-C38 BK-18

200-C38 BK-18

200-C38 BK-18

202-C44 BK-18

202-C44 BK-18

202-C44 BK-18

614-C138 PU-18

614-C138 PU-18

614-C138 PU-18

709-C140 OR-18

709-C140 OR-18

709-C140 OR-18

J764-C141 BR-16

J764-C141 BR-16

J764-C141 BR-16

202-C73 BK-18

M700-C165 BR-18G985-C166 PU-18

CONN TO LW-C1LH WIPER HARN[LOC SH 3 I-2]

322-P5 GY-14

322-P5 GY-14

322-P5 GY-14

N970-P187 YL-18N973-P188 BR-18

127-P192 RD-18

127-P192 RD-18200-P15 BK-18

200-P15 BK-18

200-P15 BK-18

195-P26 YL-18

195-P26 YL-18

195-P26 YL-18

403-P27 GN-18

403-P27 GN-18

403-P27 GN-18

N957-P80 PK-18

N979-P73 GN-18

N979-P73 GN-18

N960-P77 OR-18

N960-P77 OR-18

567-C7 WH-18

125-C3 OR-14

125-C3 OR-14

125-C3 OR-14

125-C11 OR-14

125-C11 OR-14

125-C10 OR-14

125-C10 OR-14

524-C196 BU-16

523-C91 BR-16

200-C125 BK-16120-C112 YL-16

CONN TO AC-C4HVAC HARN

[LOC SH 3 D-2]


[LOC SH 3 D-2]

125-C9 OR-16

125-C9 OR-16

C558-C12 BU-14

C558-C12 BU-14

C558-C12 BU-14

C558-C12 BU-14C546-C101 WH-16

C546-C101 WH-16

C546-C101 WH-16

A528-C102 YL-16

A528-C102 YL-16

A528-C102 YL-16

A528-C102 YL-16

200-C123 BK-12

200-C123 BK-12

200-C123 BK-12

200-C95 BK-10

200-C95 BK-10

200-C142 BK-14

200-C142 BK-14

L872-P24 BU-14

L872-P24 BU-14

L872-P24 BU-14

L872-P199 BU-14

L872-P199 BU-14

L872-P28 BU-14

L872-P28 BU-14 L872-P28 BU-14

CONN TO GF-C1ACCUGRADE FR HARN[LOC SH 3 B-14]

CONN TO FP-C1FUSE PNL HARN[LOC SH 2 C-7]

A101-P178 GN-14

A101-P178 GN-14

124-C16 GN-12

124-C16 GN-12

CONN TO GP-C1 ACCUGRADE PM400 HARN

[LOC SH 3 A-15]

200-C147 BK-18

200-C147 BK-18

709-P31 OR-18

709-P31 OR-18

709-P31 OR-18

J764-P76 BR-18

J764-P76 BR-18

J764-P76 BR-18

C831-P78 GN-18

C831-P78 GN-18

C831-P78 GN-18

C831-P78 GN-18

C831-P78 GN-18

129-C19 BU-16

129-C19 BU-16

202-LA19 BK-18

202-RA23 BK-18

E912-C36 PU-18E913-C37 YL-18

R997-P88 OR-18

R997-P88 OR-18

R997-P88 OR-18

A499-P90 BU-18

R993-P89 BR-18

A499-P90 BU-18A499-P90 BU-18

R993-P89 BR-18

614-C182 PU-18

614-C182 PU-18

614-C182 PU-18

202-C151 BK-18

202-C151 BK-18

202-C151 BK-18

127-P107 RD-18

127-P107 RD-18

127-P107 RD-18

200-P122 BK-18

200-P122 BK-18

200-P122 BK-18

195-P131 YL-18

195-P131 YL-18

195-P131 YL-18

403-P143 GN-18

403-P143 GN-18

403-P143 GN-18


[LOC SH 3 E-5]

Y934-P144 WH-18

J943-P83 GN-18

709-P30 OR-18

709-P30 OR-18

709-P30 OR-18

J764-P33 BR-18

J764-P33 BR-18

J764-P33 BR-18869-P74 PU-18

869-P74 PU-18

869-P74 PU-18

TO HYD CALSENSOR

202-C198 BK-18

202-C198 BK-18

202-C198 BK-18

202-C73 BK-18202-C44 BK-18

202-C29 BK-18

202-C199 BK-16

202-C199 BK-16

184-C108 BU-14

184-C108 BU-14

614-C184 PU-18

614-C184 PU-18

614-C184 PU-18

130-P13 RD-14

130-P13 RD-14

130-P13 RD-14

103-C152 YL-14

202-C23 BK-18

202-C23 BK-18

643-C25 GN-18

643-C25 GN-18

643-C25 GN-18

643-C25 GN-18 643-P75 GN-18

643-P75 GN-18

643-P75 GN-18

J994-C68 GY-18

J994-C68 GY-18J994-C185 GY-18

J994-C185 GY-18

J994-C26 GY-18

J994-C26 GY-18

J994-C26 GY-18

614-C21 PU-18

647-C22 GN-16643-C25 GN-18

J993-C187 PK-18

J994-C185 GY-18J992-C186 YL-18

J994-C68 GY-18

614-C192 PU-18614-C193 PU-18

J994-P79 GY-18

J994-P79 GY-18

J994-P79 GY-18

CONNS TO F-C11CASE HARNESS

[LOC SH 2 H-12]

AIR SEAT

CONN TO AIR SEAT(HEATED SEAT ATCH)

608-R9 GN-18

608-R9 GN-18

608-R9 GN-18200-R8 BK-18

200-R8 BK-18

200-R8 BK-18

607-R10 PK-18

607-R10 PK-18

607-R10 PK-18

200-R11 BK-18

200-R11 BK-18

200-R11 BK-18

CONN TO AIR SEAT(HEATED SEAT ATCH)

200-A7 BK-16

200-A7 BK-16

180-A1 RD-16

180-A1 RD-16

200-C183 BK-18200-C183 BK-18

200-C183 BK-18

L872-C162 BU-14

L872-C162 BU-14

L872-C162 BU-14

L872-C162 BU-14

L872-C162 BU-14

158-C66 BR-14

158-C66 BR-14

158-C66 BR-14

158-C66 BR-14

158-C66 BR-14

751-P67 GN-18

751-P67 GN-18

751-P67 GN-18 751-P67 GN-18

751-P67 GN-18

752-P68 YL-18

752-P68 YL-18

752-P68 YL-18 752-P68 YL-18

752-P68 YL-18

975-P63 WH-18

975-P63 WH-18

975-P63 WH-18

975-P63 WH-18

975-P63 WH-18

E918-P128 GN-18

E918-P128 GN-18

E918-P128 GN-18

E918-P128 GN-18

E918-P128 GN-18

H708-P129 OR-18

H708-P129 OR-18

H708-P129 OR-18

H713-P69 PK-18

H713-P69 PK-18

H713-P69 PK-18

H713-P69 PK-18

H713-P69 PK-18

H714-P70 OR-18

H714-P70 OR-18

H714-P70 OR-18

H714-P70 OR-18

H714-P70 OR-18

H802-P64 GY-18

H802-P64 GY-18

H802-P64 GY-18

M928-P65 BU-18

M928-P65 BU-18M928-P65 BU-18

M928-P65 BU-18

M928-P65 BU-18

M929-P66 WH-18

M929-P66 WH-18M929-P66 WH-18

M929-P66 WH-18

M929-P66 WH-18

184-P124 BU-14

184-P124 BU-14

184-P124 BU-14

CONN TO EH-C1EH HARNESS

[LOC SH 2 C-12]

CONN TO PL-C1PROD LINK 121SR HARN

[LOC SH 3 H-5]

122-C56 BU-16200-C119 BK-16

527-C197 GN-16526-C58 YL-16

892-P213 BR-18

892-P213 BR-18

892-P213 BR-18

892-P214 BR-18

893-P217 GN-18893-P216 GN-18

893-P216 GN-18

893-P216 GN-18

202-C200 BK-18

202-C200 BK-18

202-C200 BK-18

200-C201 BK-18

200-C201 BK-18

200-C201 BK-18

614-C202 PU-18

614-C202 PU-18

614-C202 PU-18

N809-C203 OR-18

N809-C203 OR-18

N809-C203 OR-18

N809-C203 OR-18

N809-C203 OR-18

N825-C204 PK-18

N825-C204 PK-18

N825-C204 PK-18

N825-C204 PK-18

N825-C204 PK-18

N824-C205 PK-18

N824-C205 PK-18

N824-C205 PK-18

N824-C205 PK-18

N824-C205 PK-18

195-C206 YL-18

195-C206 YL-18

195-C206 YL-18

200-C207 BK-18

200-C207 BK-18

200-C207 BK-18

202-C208 BK-18

202-C208 BK-18

202-C208 BK-18

614-C209 PU-18

614-C209 PU-18

614-C209 PU-18

195-C210 YL-18

195-C210 YL-18

195-C210 YL-18

N805-C211 BU-18

N805-C211 BU-18

N805-C211 BU-18

N805-C211 BU-18

N805-C211 BU-18

N822-C212 BR-18

N822-C212 BR-18

N822-C212 BR-18

N822-C212 BR-18

N822-C212 BR-18

N821-C213 GN-18

N821-C213 GN-18

N821-C213 GN-18

N821-C213 GN-18

N821-C213 GN-18

N805-P225 BU-18

N805-P225 BU-18

N805-P225 BU-18N822-P226 BR-18

N822-P226 BR-18

N822-P226 BR-18

N821-P227 GN-18

N821-P227 GN-18

N821-P227 GN-18N809-P228 OR-18

N809-P228 OR-18N809-P228 OR-18

N825-P229 PK-18

N825-P229 PK-18

N825-P229 PK-18

N824-P230 PK-18

N824-P230 PK-18

N824-P230 PK-18

STD240-0101 ATCH

STD240-0101 ATCH

200-C118 BK-18103-C152 YL-14

202-C23 BK-18

200-C170 BK-18

122-C54 BU-18

527-C51 GN-16

200-C78 BK-18

614-C90 PU-18

523-C91 BR-16120-C89 YL-16

529-C92 WH-18

524-C52 BU-16

200-C86 BK-18

524-C87 BU-16120-C88 YL-18

200-C172 BK-18

118-C99 GY-16

502-C97 OR-16

200-C85 BK-18

200-C147 BK-18

527-C120 GN-18

530-C63 OR-18

122-C55 BU-18

526-C58 YL-16

614-C61 PU-18

614-C82 PU-18

503-C83 BR-16

119-C80 PK-16

507-C84 WH-18

505-C64 BU-18

200-C79 BK-18

505-C75 BU-16

119-C81 PK-16

200-C171 BK-18

502-C48 OR-18506-C106 PU-18

118-C100 GY-16

500-C148 BR-16

614-C96 PU-18

200-C191 BK-18

202-C189 BK-18202-C188 BK-18

200-C190 BK-18195-C105 YL-18

P782-C136 PK-18P781-C135 GY-18614-C174 PU-18

614-C173 PU-18

P783-C131 WH-18P784-C132 OR-18

195-C117 YL-18200-C176 BK-18202-C133 BK-18

H779-C104 GN-18

H777-C137 OR-18

202-C134 BK-18

200-C175 BK-18

893-P96 GN-18

N964-P47 BU-18

N964-P47 BU-18

N964-P47 BU-18

N964-P47 BU-18

N964-P47 BU-18

Y758-P48 PK-18

Y758-P48 PK-18

Y758-P48 PK-18

Y758-P48 PK-18

Y758-P48 PK-18

STRAP -GRND7G-1060

502-C48 OR-18

502-C97 OR-16

505-C64 BU-18

505-C75 BU-16521-C4 YL-18521-C181 YL-16

125-C11 OR-14125-C10 OR-14

119-C81 PK-16119-C80 PK-16119-C59 PK-16

118-C99 GY-16118-C100 GY-16

118-C32 GY-16

527-C51 GN-16

527-C120 GN-18

527-C197 GN-16

125-C3 OR-14

12

R-C111552269

12

R-C91552269

12

R-C151779654

34

ROOF GNDM10

NOTE A

12

R-C51552269

12

R-C61552269

12

R-C71552269

12

R-C81552269

1

2

3 4

5

6

7

8

C-C422858569

10

1

2

3 4

5

6

7

8

C-C522858569

10

1

2

3 4

5

6

7

8

C-C622858569

10

1

2

3 4

5

6

7

8

C-C722858569

10

1

2

3 4

5

6

7

8

C-C822858569

10

CONSOLE GND"M10 THD"

NOTE A

SW RH WIPER237-9158

SW RR WIPER237-9157

SW LH WIPER237-9158

SW FR WIPER237-9154

SW LIGHTS180-6615

T

HMOTOR

GND

P B+

BK

YL

GNRD

RR WIPER MOT261-7996

GND

B+ P

T

MOTOR

GN

YL

BK

FR WIPER MOT262-0319

H

RD

BKWH

DOME LAMP084-4277

-+

LH RADIO SPEAKER6T-7695

-+

RH RADIO SPEAKER6T-7695

LH RR FLOOD LAMP ATCH240-0102

BK-16BK-16

FR LH LONG RNG154-7986

FR RH LONG RNG154-7986

DK GN-20DK BU-20

HDL RH IMP CONT266-7631266-7632 SHOWN

YL-20

SWITCH B

SWITCH C

PK-20YL/BU-20OR-20

BR-20

VI-20

WH-20

SWITCH A

ROLLERPOWERGROUNDROLLER SIGNALCALIBRATION

GY-20PLUGGED

TN-20

WH-18BR-18YL-18VI-18GY-18BU-18

POWERGROUNDFNR SENSOROPENOPENSTEERING SNSR

BASE LH HYSTAT CONT284-8207

WH-18BR-18YL-18VI-18GY-18BU-18

POWERGROUNDFNR SENSOROPENOPENSTEERING SNSR

BASE RH IMP CONT253-9544

1

2

3 4

5

6

7

8

C-C2922858569

10

SW PARK. BK190-8478

1

2

3 4

5

6

7

8

C-C1222858569

10

FC-C31552267

ABC

12

FC-C41552272

34

ABC

CAN A TERM RES 1134-2540

INSTR CLUSTER CMPT254-4091

BAT. + (POS)BAT. GND

CAN HIGHCAN LOWCAN SHIELD

PARK LAMPS

KEY SWITCH

CHASSIS GND

HORNSUP INT USE

SW SERV BK191-3587

BK-16WH-16GN-16

WH-18BK-18OR-18 BAT.

GNDSIG

SNSR PEDAL BK DCLR224-5530FC-C5

1552267ABC

1

2

3 4

5

6

7

8

C-C1322858569

10

12

FC-C71552272

34

SW THROTTLE106-0107

COMS1S2S3S4

12345

BK-18PK-18BU-18GN-18BR-18

12

C-C111552273

3456

STONOFF

BSC

R

SW START110-7887

1234

YL-16PU-16OR-16BR-16

12

R-C31552264

345678

BAT. + MEMORY

SPEAKER LH +GROUND

SPEAKER RH -GY/VI/BK

BKGN/WH

GN/WH/BK

RDYL

GY/VI

SPEAKER LH -

NC

BAT. + (12V)

SPEAKER RH +

RADIO AM FM CD248-4152

12

R-C141552269

KEY SWITCH ON

CAT DATA LINK (+)5V SENSOR SUPPLY

BACKUP ALARMNEGATIVE BATTERY 1 (-)

ENGINE SPEED SNSR -

CAT DATA LINK (-)5V SENSOR RETURN

NEGATIVE BATTERY 2 (-)

WINCH DRIVE AWAY (N/C) (CAB)

SEER (N/C)

MY SP SW (N/C)MY SP SW (N/O)

TRACK SP SNSR SPLY (8V)TRACK SP SNSR RTN (8V)

POSITIVE BATTERY 3 (+)LEFT PUMP FORWARD SOL

WINCH DRIVE AWAY (N/O) (CAB)

MACHINE CONTROL262-1408

J1

KEY SWITCH (CRANK)IMP SHUTOFF SOL

HYSTAT OVERRIDE SOL

SERVICE BRAKE SW (N/C)

BLADE ANGLE SNSR

J2

ENGINE SPEED SNSR +

FUEL LEVEL SENDERPOSITIVE BATTERY 1 (+)

PARK BRAKE SW (N/C)PARK BRAKE SW (N/O)

HYDRAULIC OIL TEMP SENDER

SNSR PRESS. OVRD ANLGPOSITIVE BATTERY 4 (+)POSITIVE BATTERY 2 (+)

ON/OFF DRIVER RTN 1-4

START RELAY RETURNWN DR AWAY LAMP

ALTERNATOR R TERMINAL5TH FUNCTION HANDLE (CUSTOM)

LEFT PUMP REVERSE SOLPWM DRIVER RETURN (1-4)RIGHT PUMP FORWARD SOLRIGHT PUMP REVERSE SOL

PWM DRVR RTN (9-12)10V SENSOR RETURN

NEGATIVE BATTERY 3 (-)LEFT MOTOR SOLRIGHT MOTOR SOL

PWM DRIVER RETURN (5-8)BLADE TILT RIGHT SOLBLADE TILT LEFT SOL

SW AUTO/MANUAL SELECT (N/O)

BLADE RAISE SOLSOL BLADE ANGLE RIGHTSOL BLADE ANGLE LEFT

BLADE LOWER SOLJOYSTICK CONT/PHS/LIGHT BAR/VARIOUS SNSRS

NEGATIVE BATTERY 4 (-)

WINCH BRAKE SOLPARK BRAKE SOL

START RELAY

4TH VALVE FLOAT INDICATOR

SEER INDICATOR

DCLR PEDAL SIGNALJOYSTICK STEERING SNSR

JOYSTICK FNR SNSRIMPL PRESS SNSR

SERVICE BRAKE SW (N/O)4TH VALVE CYL EXTEND4TH VALVE CYL RETRACT

WORK LAMP STATUS

BLADE RAISE SELECT SNSRBLADE TILT SELECT SNSR4TH VALVE FLOAT (N/C)

WINCH FREE SPOOL (N/C) (CAB)

SEER (N/O)4TH VALVE PARITY

RIGHT TRACK SPEED SIGNAL ARIGHT TRACK SPEED SIGNAL BLEFT TRACK SPEED SIGNAL ALEFT TRACK SPEED SIGNAL B

SW OPR PRESENCE (N/O)SW OPR PRESENCE (N/C)IMP LOCKOUT SW (N/O)IMP LOCKOUT SW (N/C)4TH VALVE FLOAT (N/O)RIPPER (WINCH) LEVER

SNSR WINCH PRESS.ACCEL/DCLR THUMB ROLLER

SW INCREMENT (N/O)SW DECREMENT (N/O)

SW AUTO/MANUAL SELECT (N/C)THROTTLE SWITCH POS S1

CAN A DATA LINK +

THROTTLE SWITCH POS S2THROTTLE SWITCH POS S3THROTTLE SWITCH POS S4CHARGE FILTER BYPASS SW

CAN (B) DATA LINK (+)CAN (B) DATA LINK (-)

CAN A DATA LINK -

WINCH FREE SPOOL (N/O) (CAB)

12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

WN FREE SPOOL CAB LAMP

CAN (A) DATA LINK (+)CAN (A) DATA LINK (-)

WN 4th V FNCT - ADDRESS IN

WN 4th V FNCT - ADDRESS OUT

CALSIGNALGROUNDPOWER

VI-18

YL-18BR-18WH-18

S AXIS HDL WN RIP.307-4673

12

C-C191552272

34

12345678910111213141516171819

P-C21977261

MOM

SW WN DRIVE AWAY249-9047

1

2

3 4

5

6

7

8

C-C122858569

10

MOM

SW WN FREE SPOOL249-9037

1

2

3 4

5

6

7

8

C-C1722858569

10

123456789101112131415161718192021222324

C-C212253854

25262728293031

HORN ACTION ALM232-1792

123456789101112

FC-C63E5179

12

C-C21552252

3456789101112

12

C-C151552272

34

123456789101112

C-C223E5179

12

C-C231552272

34

C-C281552267

ABC

12

FC-C81552264

345678

SW IMP LOCKOUT245-6033

12

FC-C12304009

3456789101112

123456789101112131415161718192021222324

P-C31471445

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

GND PLATF"M10 THD"

NOTE A

123456789101112131415161718192021222324

P-C101673692

25262728293031

MOM

MOM SW 4TH VALVE

249-90221

2

3 4

5

6

7

8

C-C2622858569

10

12

P-C151552252

3456789101112

12345678

P-C143E3388

123456789101112131415161718192021222324

P-C61471446

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

12

C-C241779654

34

12345678910111213141516171819202122232425262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

C-C202144208

12

C-C271552269

12345678

C-C103E3388

12

R-C11552264

345678

12345678

R-C103E3388

12

C-C141552264

345678

12

R-C132305008

34

12

R-C122305008

34

12

P-C191552252

3456789101112

SW AC202-2284

12

C-C161552252

3456789101112

1524

C-C189X1054

3 87a87

85

8630

RLY BLOWER HIGH115-1615

12

C-C251552272

34

DK GN-20DK BU-20

HDL LH HYSTAT CONT266-7634

YL-20

SWITCH BOR-20

BR-20

VI-20

WH-20

SWITCH A

ROLLERPOWERGROUNDROLLER SIGNALCALIBRATION

GY-20PLUGGED

TN-20

PLUGGEDPLUGGED

ABC

MOM

MOM

BK-18YL-18GN-18

BK-18BK-18

GN-18YL-18

OPERATOR PRESENCE SW216-0814

12345678

P-C123E3388

123456789101112131415161718192021222324

P-C11607690

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

12

C-C31552252

3456789101112

123456789101112

LA-C53E5179

123456789101112

RA-C51907612

12

C-C91552253

3456789101112

12

LA-C22304009

3456789101112

12

RA-C22304009

3456789101112

12

RA-C32305010

3456

12

P-C51552252

3456789101112

123456789101112

P-C43E5179

12

P-C73E3364

12

P-C111552269

12

LA-C31552273

3456

P-C203E3370

ABC

123456789101112

P-C163E5179

123456789101112

P-C171907613

BK-14BK-14

POWER PORT178-7539

12

A-C13E3364

12

P-C81552252

3456789101112

MED-HI

GND

B +

MEDLOW

HI

HVAC CONT PANEL267-5239

A/CGNDBACKLIGHTING (+)BACKLIGHTING (-)B +SIGNAL

1

2

3 4

5

6

7

8

C-C3222858569

10

1

2

3 4

5

6

7

8

C-C3022858569

10

MOM

SW SEER311-7070

MOM

SW 4TH V FLOAT311-7069

RH RR FLOOD LAMP STD240-0102

BK-16BK-16

FR LH FLOOD LAMP ATCH240-0102

FR RH FLOOD LAMP ATCH240-0102

12

P-C131552264

345678

GND FRAME"M10 THD"

NOTE A

1

A-T27X-1041

1

A-T17X-1041

1

2 200-L32 BK-14

AG-C4111-7898

L-C123E-5179

C-C4130-6795



SocketPin

AG-C3130-6795







Plug

GroundConnection

325-AG135 PK-14


Wire Gauge


T



T


Receptacle


PressureSymbol

TemperatureSymbol

LevelSymbol

FlowSymbol









Symbols




Fuse(5 Amps)

5A

KE

NR

5711-0

1 V

OL

2 o

f 3

36

Pa

ge

, (D

ime

ns

ion

s:

48

in

ch

es

x 3

5 i

nc

he

s)


Volume 2 of 3: Engine & Chassis


D3K, D4K and D5K





CASE WIRING - (F) HARNESS & ELECTRO HYDRAULIC WIRING - (EH) HARNESS ENGINE HYSTAT WIRING - (EN) HARNESS & ENGINE WIRING - (E) HARNESS

CAB WIRING - (CL) OROPS HARNESS, (FP) FUSE PANEL HARNESS, (FC) FUSE PANEL HARNESS

FUSE BLOCK WITH COVER REMOVED

2

42

16

39

57

47

76

3837

5

7170

4

45

3

7

41

40

11

6

4344

1

8

10

3335

6263

64

65

3481

32

25

28

26

30

12

29

2982

19

2021 22 23 24

27

31

13

50

4846

56

14

15

5967

66

75

7417

18

69 5549

58

54

53

7880

77

79

J2 CONNECTOR

J1 CONNECTOR

72

73

9

6061

5168

52















Component Identifiers (CID¹)Module Identifier (MID²)Engine Control System

(MID No. 036)CID Component0001 Injector Cylinder #10002 Injector Cylinder #20003 Injector Cylinder #30004 Injector Cylinder #40005 Injector Cylinder #50006 Injector Cylinder #6






















CONN 5 H-11 1CONN 6 I-11 2CONN 7 H-11 2CONN 8 E-8 3CONN 10 F-8 4CONN 11 F-8 5CONN 15 F-11 6CONN 17 B-7 7CONN 23 H-12 8CONN 24 H-12 8CONN 25 H-7 9CONN 26 C-12 10CONN 30 C-7 11CONN 31 I-14 12CONN 32 B-12 6CONN 33 H-7 13CONN 34 I-5 14CONN 35 I-5 15CONN 36 Service Connector A-3 16CONN 37 H-3 17CONN 38 I-3 18



LocationMachine Location Component Schematic


Alarm, Backup E-15 28 Sensor, Track Speed (Right) G-15 32Alternator F-7 56 Sensor, Water In Fuel H-5 51Batteries G-7 29 Sensor, Winch Pressure I-4 15Block, Fuse D-2 57 Solenoid, A/C Compressor I-7 13Breaker, Main D-7 41 Solenoid, Angle (Left) E-15 23Control, Engine H-1 68 Solenoid, Angle (Right) D-15 19Control, HVAC I-8 70 Solenoid, Blade (Lower) D-15 20Ground, Engine F-7 69 Solenoid, Blade (Raise) D-15 24Ground, Frame #1 E-7 27 Solenoid, Blade Tilt (Left) C-15 82Ground, Frame #2 E-7 69 Solenoid, Blade Tilt (Right) C-15 22Ground, O Rops A-15 1 Solenoid, Fuel Pump E-4 75Handle, Winch/Ripper B-8 43 Solenoid, Hystat Override G-5 53Horn, Forward I-4 47 Solenoid, Implement Override C-15 21Module, PRM I-4 55 Solenoid, Left Pump (Forward) H-5 60Motor, Pump (Front) I-15 65 Solenoid, Left Pump (Reverse) H-5 61Motor, Pump (LH Door) I-15 64 Solenoid, Track Moter (Left) G-15 35Motor, Pump (Rear) H-15 62 Solenoid, Track Moter (Right) G-15 34Motor, Pump (RH Door) I-15 63 Solenoid, Parking Brake G-5 54Motor, Starting F-7 49 Solenoid, Right Pump (Forward) G-5 59Plugs, Glow F-5 66 Solenoid, Right Pump (Reverse) G-5 58Port, Power H-8 71 Solenoid, Smart Mast E-4 79Relay, Blower (High) I-8 43 Solenoid, Start Aid G-5 52Relay, Horn A-7 37 Solenoid, Winch Reel (In) I-4 15Relay, Lighting #1 A-7 39 Solenoid, Winch Reel (Out) I-4 15Relay, Lighting #2 A-7 38 Suppressor, Arc F-5 48Relay, Main Power C-7 40 Suppressor, HVAC Arc I-7 13Relay, Starting E-7 55 Switch, Disconnect G-7 26Resistor, CAN 2 F-5 52 Switch, 4th Valve E-8 42Resistor, Excitation F-5 46 Switch, 4th Valve Float H-8 42Sender, Fuel Level F-15 30 Switch, A/C Refridgerent I-7 13Sensor, Coolant Temperature G-4 76 Switch, Air Inlet F-5 50Sensor, Crank Speed #1 G-4 72 Switch, Hydraulic Bypass #1 H-15 31Sensor, Crank Speed #2 G-4 74 Switch, Hydraulic Bypass #2 H-15 31Sensor, Engine Speed G-5 67 Switch, Hydraulic Bypass #3 H-15 31Sensor, Fuel Rail Pressure F-4 78 Switch, Implement Lockout A-7 45Sensor, Hydraulic Temperature F-15 25 Switch, Lights E-8 44Sensor, Intake Manifold Pressure F-4 77 Switch, Parking Brake A-7 45Sensor, Intake Manifold Temperature G-4 80 Switch, SEER H-8 45Sensor, Oil Pressure F-4 73 Switch, Throttle C-8 45Sensor, Pressure Override Analog F-15 81 Switch, Winch Drive Away D-8 42Sensor, Track Speed (Left) G-15 33 Switch, Winch Free Spool D-8 42

Volume 2 - Resistor, Sender and Solenoid SpecificationsPart No. Component Description Resistance (Ohms)¹134-2540 Resistor: CAN A 120178-9570 Solenoid: A/C Compressor 3.5 ± 0.15 @ 20°C (68°F)238-9397 Resistor: Excitation 120252-4734 Solenoid: Hystat Override, Parking Brake 7.5 ± 0.4

257-8924 Sender: Fuel Level Empty - 240-250Full - 28-33

269-4669 Solenoid:Left Pump (Forward), Left Pump (Reverse), Track Motor (Left), Track Motor (Right), Winch Reel (In), Winch Reel (Out), Right Pump (Forward), Right Pump (Reverse)

4.26 @ 20°C (68°F)

273-5070 Solenoid: Start Aid 13.25 ± 0.5¹ At room temperature unless otherwise noted.

Volume 2 - Off Machine Switch SpecificationPart No. Function Actuate Deactuate Contact Position

236-6923 A/C Refridgerent Low: 275 kPa (40 psi)High: 2800 kPa¹ (406 psi)

Low: 170 kPa¹ (25 psi)High: 1750 kPa (254 psi) Normally Closed²

¹ With increasing pressure the closed condition can be maintained up to 2800 kpa (405 psi), with decreasing pressure the closed condition can be maintained down to 170 kpa (25psi).

² Contact position at the contacts of the harness connector.

KE

NR

5711-0

1 V

OL

2 o

f 3

36

Pa

ge

, C

olo

r 2

, (D

ime

ns

ion

s:

48

in

ch

es

x 3

5 i

nc

he

s)



A

B

C

D

E

F

G

H

I

A

B

C

D

E

F

G

H

I

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

ABBREV COLORRD REDWH WHITEOR ORANGEYL YELLOWPK PINKBK BLACKGY GRAYPU PURPLEBR BROWNGN GREENBU BLUE

COLOR ABBREVIATIONS SYMBOL DESCRIPTION


CIRCUIT CONNECTED


ELECTRICAL CONNECTION TO MACHINE STRUCTUREINTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT

CONNECTOR


CIRCUIT CONNECTED

SPLICE







RS-232 DATA LINK.

CAN DATA LINK D.


CAN DATA LINK B.


WINCH CONTROL CIRCUIT.

CONN 31

CONN 32

CONN 26

CONN 23

CONN 7

CONN 5

CONN 15

CONN 6

CONN 24

CONN 8

CONN 10

CONN 11

CONN 25

CONN 33

CONN 35

CONN 34

CONN 37

CONN 38

CONN 36

CONN 30

CONN 17

589-AE3 GN-16

ENGINE

HVAC ENGINE

F712-EN42 GY-18

F712-EN42 GY-18

F711-EN44 GN-18

F711-EN44 GN-18

F711-EN43 GN-18

F712-EN41 GY-18

F712-EN41 GY-18

522-EN27 WH-16

F711-EN43 GN-18

195-EN34 YL-18

H451-EN40 GN-18

521-AE4 YL-16

589-AE5 GN-18

589-AE1 GN-18

522-AE6 WH-18

522-AE2 WH-18

CONN TO P-C10 PLATF HARN

[LOC SH 1 F-3]

CONN TOSERV CONN

CBL-AA1 RD-2

CBL-FF1 RD-00CBL-EE1 RD-00

CBL-EE1 RD-00

H801-EN2 PU-18

H801-EN2 PU-18

H801-EN4 PU-18

H801-EN4 PU-18

H801-EN5 PU-18

H801-EN5 PU-18

H801-EN6 PU-18

H801-EN6 PU-18

H801-EN7 PU-18

H801-EN7 PU-18

K943-EN14 OR-18

K943-EN14 OR-18

K943-EN14 OR-18

K944-EN24 YL-18

K944-EN24 YL-18

K944-EN24 YL-18K946-EN31 OR-18

K946-EN31 OR-18

K946-EN31 OR-18

K947-EN25 YL-18

K947-EN25 YL-18

K947-EN25 YL-18

430-EN35 BU-18

430-EN35 BU-18

A287-EN36 BK-18

A287-EN36 BK-18

CBL-HH1 BK-00CBL-FF1 RD-00

CBL-HH1 BK-00

H708-EN49 OR-18

H708-EN49 OR-18

H708-EN52 OR-18

H708-EN52 OR-18

A958-EN53 WH-18

A958-EN53 WH-18

FUSE PANEL

H708-EN18 OR-18

H708-EN18 OR-18

915-EN23 GN-18

915-EN23 GN-18

915-EN23 GN-18

195-EN37 YL-18

309-EN46 GY-18

309-EN46 GY-18

195-EN37 YL-18

CBL-AA1 RD-2

521-AE4 YL-16

403-EN38 GN-18

403-EN38 GN-18

403-EN38 GN-18

521-EN26 YL-16

521-EN26 YL-16

521-EN26 YL-16

OROPS CONSOLE

614-CL5 PU-18

202-CL29 BK-18202-CL29 BK-18320-CL30 OR-16

A314-CL33 OR-18

A314-CL33 OR-18

A314-CL33 OR-18

200-CL8 BK-18

200-CL6 BK-16

129-CL19 BU-16200-CL20 BK-18

200-CL8 BK-18

200-CL6 BK-16

614-CL5 PU-18

129-CL19 BU-16

200-CL20 BK-18

709-CL31 OR-18

F773-CL39 OR-18

F773-CL39 OR-18

A315-CL34 WH-18

A315-CL34 WH-18

F774-CL40 WH-18 C703-CL35 BR-18

C703-CL35 BR-18

F853-CL41 BR-18

F853-CL41 BR-18E912-CL36 PU-18

E912-CL36 PU-18

E913-CL37 YL-18

E913-CL37 YL-18

H710-CL42 PK-18

H710-CL42 PK-18

H711-CL43 GN-18

H711-CL43 GN-18

J943-CL46 GN-18

J943-CL46 GN-18

J943-CL46 GN-18

J764-CL45 BR-16

J944-CL47 BU-18

J944-CL47 BU-18

J944-CL47 BU-18

G985-CL166 PU-18

G985-CL166 PU-18

G985-CL166 PU-18

Y934-CL53 WH-18

Y934-CL53 WH-18

Y934-CL53 WH-18

K757-CL50 YL-18

K757-CL50 YL-18

K757-CL50 YL-18

K757-CL50 YL-18

R981-CL57 YL-18

R981-CL57 YL-18

R981-CL57 YL-18

M700-CL165 BR-18

M700-CL165 BR-18

M700-CL165 BR-18

J946-CL49 OR-18

J946-CL49 OR-18

J946-CL49 OR-18

202-CL65 BK-18

202-CL65 BK-18

105-CL24 RD-18

M730-CL72 YL-18

M730-CL72 YL-18

M730-CL72 YL-18

J764-CL67 BR-18

709-CL76 OR-18C992-CL70 PU-18

C992-CL70 PU-18

200-CL77 BK-12

C992-CL70 PU-18

709-CL76 OR-18

105-CL24 RD-18

308-CL103 YL-18

308-CL103 YL-18

308-CL71 YL-18

308-CL71 YL-18

F711-CL115 GN-18

F711-CL115 GN-18

F711-CL115 GN-18

F711-CL115 GN-18

F712-CL116 GY-18

F712-CL116 GY-18

F712-CL116 GY-18

F712-CL116 GY-18

647-CL22 GN-16

200-CL118 BK-18

200-CL118 BK-18

103-CL152 YL-14

614-CL21 PU-18

614-CL21 PU-18

A755-CL126 PK-18

A755-CL126 PK-18

A755-CL126 PK-18

A756-CL127 BU-18

A756-CL127 BU-18

A756-CL127 BU-18

A757-CL128 GY-18

A757-CL128 GY-18

A757-CL128 GY-18

A758-CL129 BR-18

A758-CL129 BR-18

A758-CL129 BR-18

202-CL130 BK-18

202-CL130 BK-18

P784-CL132 OR-18

P784-CL132 OR-18

P784-CL132 OR-18

P783-CL131 WH-18

P783-CL131 WH-18

P783-CL131 WH-18

202-CL133 BK-18

202-CL133 BK-18

202-CL134 BK-18

202-CL134 BK-18

P781-CL135 GY-18

P781-CL135 GY-18

202-CL146 BK-14202-CL146 BK-14

H710-CL42 PK-18H711-CL43 GN-18

F773-CL39 OR-18F774-CL40 WH-18

C703-CL35 BR-18

F853-CL41 BR-18

E912-CL36 PU-18E913-CL37 YL-18

H710-CL42 PK-18H711-CL43 GN-18

J943-CL46 GN-18

J764-CL45 BR-16

J944-CL47 BU-18

G985-CL166 PU-18

Y934-CL53 WH-18R981-CL57 YL-18

M700-CL165 BR-18

J946-CL49 OR-18

M730-CL72 YL-18

A755-CL126 PK-18A756-CL127 BU-18A757-CL128 GY-18A758-CL129 BR-18

P784-CL132 OR-18P783-CL131 WH-18

320-CL30 OR-16

A315-CL34 WH-18

F774-CL40 WH-18

105-CL24 RD-18

J764-CL67 BR-18

C992-CL70 PU-18

308-CL71 YL-18

CONN TO DASH HARNFC-C6

[LOC SH 1 E-12]

CONN TO RA-C5RIGHT ARM HARNESS[LOC SH 1 G-11]

CONN TO AIR SEAT[LOC SH 1 G-11]

515-CL1 GY-12

200-RL30 BK-18

200-RL30 BK-18

607-RL32 PK-18

607-RL32 PK-18

607-RL33 PK-18

607-RL33 PK-18

200-RL35 BK-18

200-RL35 BK-18

200-RL48 BK-14

200-RL48 BK-14

200-RL49 BK-14

200-RL49 BK-14

607-RL51 PK-14

607-RL51 PK-14

608-RL52 GN-14

608-RL52 GN-14

608-RL9 GN-18

608-RL9 GN-18

200-RL8 BK-18

200-RL8 BK-18

607-RL10 PK-18

607-RL10 PK-18

200-RL11 BK-18

200-RL11 BK-18

608-RL1 GN-18

608-RL1 GN-18

200-RL12 BK-18

200-RL12 BK-18 608-RL13 GN-18

608-RL13 GN-18

200-RL15 BK-18200-RL15 BK-18

200-CL17 BK-18

200-CL17 BK-18

OROPS ROOF

C959-F1 BR-18

C959-F1 BR-18C959-F1 BR-18

C958-F3 BU-18

C958-F3 BU-18

C958-F3 BU-18

H802-F2 GY-18

H802-F2 GY-18H802-F4 GY-18

H802-F4 GY-18H802-F26 GY-18

H802-F26 GY-18

R993-F6 BR-18

321-F9 BR-18

321-F9 BR-18

321-F9 BR-18

447-F5 PK-18

447-F5 PK-18

447-F5 PK-18

G434-F7 BU-18

G434-F7 BU-18

G434-F7 BU-18

J765-F10 BU-18

J765-F10 BU-18

J765-F10 BU-18

M792-F27 BU-16

M792-F27 BU-16

M792-F28 BU-16

M792-F28 BU-16M792-F29 BU-18

M792-F29 BU-18

497-F23 BU-18

497-F23 BU-18

497-F34 BU-18

497-F34 BU-18

J766-F31 PU-18

J766-F31 PU-18

J766-F30 PU-18

J766-F30 PU-18

497-F32 BU-18 497-F32 BU-18

J766-F33 PU-18

J766-F33 PU-18

770-F35 GN-18

770-F35 GN-18

770-F35 GN-18

769-F37 BU-18

769-F37 BU-18

769-F37 BU-18

835-F38 PU-18

835-F38 PU-18

835-F38 PU-18

833-F36 GY-18

833-F36 GY-18833-F36 GY-18

M792-WH1 BU-16

CASE

CBL-HH2 BK-00

CBL-HH2 BK-00

CBL-CC1 BK-00

522-AE7 WH-16

102-FP4 BU-14102-FP4 BU-14

102-FP4 BU-14

103-FP5 YL-14

103-FP5 YL-14

105-FP7 RD-18

105-FP7 RD-18

105-FP7 RD-18

124-FP9 GN-12

124-FP9 GN-12

124-FP9 GN-12

126-FP10 PK-14

126-FP10 PK-14

129-FP11 BU-16

129-FP11 BU-16

129-FP11 BU-16180-FP13 GN-14

180-FP13 GN-14

180-FP13 GN-14195-FP14 YL-14

195-FP14 YL-14

195-FP14 YL-14

A101-FP15 GN-14

A101-FP15 GN-14

A101-FP15 GN-14

184-FP17 BU-14

184-FP17 BU-14

158-FP18 BR-12

158-FP18 BR-12

158-FP18 BR-12

159-FP19 BU-12159-FP19 BU-12

159-FP19 BU-12

122-FP20 BU-16

122-FP20 BU-16

122-FP20 BU-16

118-FP21 GY-16

118-FP21 GY-16

118-FP21 GY-16

119-FP22 PK-16

119-FP22 PK-16

119-FP22 PK-16

120-FP23 YL-16

120-FP23 YL-16

120-FP23 YL-16

106-FP24 WH-18

106-FP24 WH-18

200-FP3 BK-18308-FP2 YL-18

CBL-FF4 RD-2

115-FP26 RD-10

115-FP26 RD-10

112-FP27 PU-10

112-FP27 PU-10

112-FP28 PU-10

112-FP28 PU-10

112-FP29 PU-10

112-FP29 PU-10

112-FP30 PU-10

112-FP30 PU-10

112-FP30 PU-10

112-FP31 PU-10

112-FP31 PU-10

112-FP31 PU-10

112-FP32 PU-10

112-FP32 PU-10

112-FP32 PU-10

115-FP35 RD-10

115-FP35 RD-10110-FP16 RD-16

110-FP16 RD-16

110-FP16 RD-16

108-FP33 RD-18

108-FP33 RD-18

108-FP33 RD-18

304-EN28 WH-12

304-EN28 WH-12

306-EN47 GN-16

306-EN47 GN-16

306-EN47 GN-16

J765-EN59 BU-16

J765-EN59 BU-16

J765-EN59 BU-16

112-FP28 PU-10

115-FP26 RD-10112-FP29 PU-10

112-FP27 PU-10

110-FP16 RD-16

102-FP4 BU-14

195-FP14 YL-14

105-FP7 RD-18

129-FP11 BU-16

180-FP13 GN-14

A101-FP15 GN-14

115-FP35 RD-10

103-FP34 YL-14

103-FP34 YL-14

103-FP36 YL-14

103-FP36 YL-14

103-FP36 YL-14

647-FP37 GN-16

647-FP37 GN-16

647-FP38 GN-16

647-FP38 GN-16

647-FP39 GN-16

647-FP39 GN-16200-FP41 BK-16

200-FP41 BK-16

200-FP40 BK-16

200-FP40 BK-16

200-FP42 BK-18

200-FP42 BK-18

607-FP43 PK-14

607-FP43 PK-14

607-FP43 PK-14

608-FP44 GN-14

608-FP44 GN-14

184-FP17 BU-14

114-FP8 RD-14

114-FP8 RD-14

114-FP8 RD-14

114-FP45 RD-14

114-FP45 RD-14

114-FP46 RD-16

114-FP46 RD-16

322-FP48 GY-14

322-FP48 GY-14

322-FP48 GY-14

320-FP47 OR-16

320-FP47 OR-16

320-FP47 OR-16

CONN TO GC-C1ACCUGRADECSL HARN

[LOC SH 3 H-13]

124-CL16 GN-12

124-CL16 GN-12

200-CL77 BK-12

200-CL77 BK-12

202-CL146 BK-14

200-CL142 BK-14

124-FP49 GN-14

124-FP49 GN-14

124-FP50 GN-14

124-FP50 GN-14

607-CL121 PK-14608-CL122 GN-14

F853-CL41 BR-18F774-CL40 WH-18F773-CL39 OR-18

E913-CL37 YL-18E912-CL36 PU-18

C703-CL35 BR-18

A315-CL34 WH-18A314-CL33 OR-18

709-CL31 OR-18

709-CL155 OR-18

J764-CL154 BR-18

J948-CL157 PK-18

184-FP51 BU-14

184-FP51 BU-14

184-FP52 BU-14

184-FP52 BU-14

200-FP53 BK-18

200-FP53 BK-18

200-FP53 BK-18

892-FP54 BR-18892-FP54 BR-18

892-FP54 BR-18

892-FP54 BR-18

893-FP55 GN-18

893-FP55 GN-18

893-FP55 GN-18

893-FP55 GN-18

126-FP62 PK-18

126-FP62 PK-18

126-FP62 PK-18126-FP63 PK-14

126-FP63 PK-14

115-EN62 RD-12

CBL-FF4 RD-2

CONN TO P-C2PLATF HARN

[LOC SH 1 B-3]

158-FP66 BR-14158-FP66 BR-14

200-FP3 BK-18

158-FP65 BR-14158-FP65 BR-14

159-FP67 BU-14

159-FP67 BU-14

159-FP68 BU-14

159-FP68 BU-14

506-FP69 PU-18

507-FP70 WH-18

507-FP70 WH-18

507-FP70 WH-18

529-FP71 WH-18

529-FP71 WH-18

529-FP71 WH-18530-FP72 OR-18

530-FP72 OR-18

530-FP72 OR-18

310-EN19 PU-8

310-EN19 PU-8

195-EN58 YL-14

195-EN58 YL-14

115-EN62 RD-12

202-EN65 BK-14

450-EN74 YL-18

450-EN74 YL-18

451-EN75 BR-18

451-EN75 BR-18

A958-EN53 WH-18

127-EN1 RD-14

127-EN1 RD-14

F711-FP73 GN-18F711-FP73 GN-18

F711-FP73 GN-18

F712-FP74 GY-18

F712-FP74 GY-18

F712-FP74 GY-18

F712-FP74 GY-18

522-EN27 WH-16

522-EN27 WH-16

WINCH-RIPPERLEVER (ATCH)

M792-WH1 BU-16

309-EN46 GY-18

J807-EN76 BK-18

J807-EN76 BK-18J808-EN77 BK-18

J808-EN77 BK-18

F869-EN78 PK-18

F869-EN78 PK-18F868-EN79 OR-18

CASE

195-CL105 YL-18

195-CL105 YL-18

P782-CL136 PK-18

P782-CL136 PK-18

P782-CL136 PK-18

P782-CL136 PK-18

H777-CL137 OR-18

H777-CL137 OR-18

H777-CL137 OR-18

H777-CL137 OR-18

P781-CL135 GY-18

P781-CL135 GY-18

195-CL117 YL-18

195-CL117 YL-18

H779-CL104 GN-18

H779-CL104 GN-18

H779-CL104 GN-18

H779-CL104 GN-18

F931-CL114 PK-18

F931-CL114 PK-18

F931-CL114 PK-18

F931-CL114 PK-18

307-CL107 OR-18

307-CL107 OR-18

307-CL107 OR-18

307-CL107 OR-18

709-CL155 OR-18

709-CL155 OR-18

CONN TO C-C21CAB HARN[LOC SH 1 B-2]

709-CL156 OR-18

709-CL156 OR-18J764-CL154 BR-18

J948-CL157 PK-18

J948-CL157 PK-18

180-CL62 GN-14

180-CL62 GN-14

180-CL62 GN-14

200-CL27 BK-18

110-CL98 RD-16

110-CL98 RD-16

110-CL98 RD-16

184-CL108 BU-14

892-CL110 BR-18

892-CL110 BR-18

892-CL110 BR-18

893-CL143 GN-18

893-CL143 GN-18

893-CL143 GN-18

K960-CL161 PK-18

K960-CL161 PK-18

K960-CL161 PK-18

K961-CL158 GN-18

K961-CL158 GN-18

K961-CL158 GN-18

608-CL122 GN-14

607-CL121 PK-14

607-CL121 PK-14

L856-CL164 YL-18

L856-CL164 YL-18

L856-CL164 YL-18

L857-CL159 GN-18

L857-CL159 GN-18

L857-CL159 GN-18

T744-CL160 WH-14

T744-CL160 WH-14

T744-CL160 WH-14

J948-CL157 PK-18

200-CL142 BK-14

200-CL95 BK-12

WINCH FILTERBYPASS SWITCH

(ATCH)

WASHER PUMPS

200-Y1 BK-18

200-Y1 BK-18

200-Y2 BK-18

200-Y2 BK-18

200-Y3 BK-18

200-Y3 BK-18

200-Y4 BK-18

200-Y4 BK-18

200-F11 BK-18

200-Y9 BK-18

200-Y9 BK-18

530-F12 OR-18529-F13 WH-18

506-F14 PU-18

507-F15 WH-18

506-Y7 PU-18

506-Y7 PU-18

506-Y7 PU-18

507-Y8 WH-18

507-Y8 WH-18

507-Y8 WH-18

529-Y5 WH-18

529-Y5 WH-18

529-Y5 WH-18

530-Y6 OR-18 530-Y6 OR-18

530-Y6 OR-18

124-CL94 GN-14

124-CL94 GN-14

124-CL93 GN-14

124-CL93 GN-14

308-CL150 YL-18

202-CL44 BK-18

202-CL44 BK-18

200-CL175 BK-18

200-CL175 BK-18

200-CL176 BK-18

200-CL176 BK-18

614-CL173 PU-18

614-CL173 PU-18

614-CL174 PU-18

614-CL174 PU-18

195-CL177 YL-18

195-CL177 YL-18

195-CL177 YL-18

321-F9 BR-18447-F5 PK-18

497-F32 BU-18

769-F37 BU-18770-F35 GN-18

833-F36 GY-18

835-F38 PU-18

C958-F3 BU-18

C959-F1 BR-18

G434-F7 BU-18H802-F26 GY-18J765-F10 BU-18J766-F33 PU-18M792-F29 BU-18

530-F12 OR-18529-F13 WH-18507-F15 WH-18200-F11 BK-18

506-F14 PU-18

R993-F6 BR-18

R993-F6 BR-18

R993-F24 BR-18

R993-F24 BR-18

R993-F8 BR-18

R993-F8 BR-18

J764-CL153 BR-18

J764-CL153 BR-18

J764-CL153 BR-18

184-CL108 BU-14

614-CL169 PU-18

614-CL193 PU-18

614-CL193 PU-18

614-CL192 PU-18

614-CL192 PU-18

200-CL191 BK-18

200-CL191 BK-18

200-CL190 BK-18

200-CL190 BK-18

J992-CL186 YL-18

J992-CL186 YL-18

J992-CL186 YL-18

J992-CL186 YL-18

J993-CL187 PK-18

J993-CL187 PK-18

J993-CL187 PK-18

J993-CL187 PK-18

202-CL188 BK-18

202-CL188 BK-18

202-CL189 BK-18

202-CL189 BK-18

CBL-CC1 BK-00

106-FP24 WH-18

200-CL95 BK-12

200-CL95 BK-12

WINCH (ATCH)

195-EN57 YL-18

202-EN65 BK-14

450-EN74 YL-18451-EN75 BR-18

122-FP20 BU-16

118-FP21 GY-16119-FP22 PK-16120-FP23 YL-16

115-FP26 RD-10

112-FP27 PU-10112-FP28 PU-10112-FP29 PU-10112-FP30 PU-10112-FP31 PU-10112-FP32 PU-10

115-FP35 RD-10

108-FP33 RD-18106-FP24 WH-18

126-FP10 PK-14

105-CL24 RD-18

105-CL24 RD-18

200-CL27 BK-18

308-CL150 YL-18

647-CL22 GN-16

647-CL22 GN-16

129-CL19 BU-16

320-CL30 OR-16

103-CL152 YL-14

110-CL98 RD-16

607-CL121 PK-14

608-CL122 GN-14

608-CL122 GN-14

996-E70 GN-18

996-E70 GN-18

996-E69 GN-18

996-E69 GN-18996-E10 GN-18

996-E10 GN-18

L731-E68 BR-18

L731-E68 BR-18

L731-E66 BR-18

L731-E66 BR-18

L731-E37 BR-18

L731-E37 BR-18

E965-E52 BU-18

E965-E52 BU-18

E965-E52 BU-18

P920-E53 BR-18

P920-E53 BR-18

P920-E53 BR-18

995-E43 BU-18

995-E43 BU-18

995-E43 BU-18

C967-E42 BU-18

C967-E42 BU-18

C967-E42 BU-18

T997-E46 OR-18

T997-E46 OR-18

T997-E46 OR-18

T993-E38 BR-18

T993-E38 BR-18

T993-E38 BR-18

X731-E55 BU-18

X731-E55 BU-18

X731-E55 BU-18

Y946-E51 BU-18

Y946-E51 BU-18

Y946-E51 BU-18

Y948-E40 BR-18

Y948-E40 BR-18

Y948-E40 BR-18

R997-E48 OR-18

R997-E48 OR-18

R997-E48 OR-18

L730-E47 OR-18

L730-E47 OR-18

L730-E47 OR-18

Y947-E39 BR-18

Y947-E39 BR-18

Y947-E39 BR-18

994-E56 GY-18

994-E56 GY-18

994-E56 GY-18

Y950-E25 YL-18

Y950-E25 YL-18

Y950-E25 YL-18

Y951-E26 PU-18

Y951-E26 PU-18

Y951-E26 PU-18

M795-E17 WH-18

M795-E17 WH-18

M795-E17 WH-18

C211-E44 BK-18

C211-E44 BK-18

C211-E44 BK-18

X929-E8 BU-18

X929-E8 BU-18

X929-E8 BU-18

X923-E64 OR-18

X923-E64 OR-18

X923-E64 OR-18

X928-E33 GN-18

X928-E33 GN-18

X928-E33 GN-18

X922-E59 WH-18

X922-E59 WH-18

X922-E59 WH-18X927-E34 YL-18

X927-E34 YL-18

X927-E34 YL-18

X921-E58 PK-18

X921-E58 PK-18

X921-E58 PK-18

X926-E35 GY-18

X926-E35 GY-18

X926-E35 GY-18

X920-E57 BR-18

X920-E57 BR-18

X920-E57 BR-18

X929-E8 BU-18

X922-E59 WH-18

X928-E33 GN-18

X923-E64 OR-18

X921-E58 PK-18

X926-E35 GY-18

X920-E57 BR-18

X927-E34 YL-18

893-EN21 GN-18

893-EN21 GN-18

893-EN21 GN-18

892-EN20 BR-18

892-EN20 BR-18

892-EN20 BR-18

892-EN20 BR-18893-EN21 GN-18

A287-EN36 BK-18

430-EN35 BU-18

A287-EN36 BK-18430-EN35 BU-18

202-EN3 BK-18

202-EN3 BK-18

202-EN3 BK-18

202-EN8 BK-18

202-EN8 BK-18

202-EN8 BK-18

202-EN9 BK-18

202-EN9 BK-18

202-EN9 BK-18

127-EN10 RD-18

127-EN10 RD-18

127-EN10 RD-18

127-EN11 RD-18

127-EN11 RD-18

127-EN11 RD-18

127-EN33 RD-18

127-EN33 RD-18

127-EN33 RD-18

127-EN13 RD-18

127-EN13 RD-18

127-EN13 RD-18

202-EN16 BK-18

202-EN16 BK-18

202-EN16 BK-18

200-EN39 BK-18

200-EN39 BK-18

F711-EN17 GN-18

F711-EN17 GN-18

F711-EN17 GN-18

F712-EN22 GY-18

F712-EN22 GY-18

F712-EN22 GY-18

195-EN29 YL-18

195-EN29 YL-18

195-EN29 YL-18

375-EN83 BR-18

375-EN83 BR-18

375-EN83 BR-18

195-EN34 YL-18

T952-EK3 BK-18T958-EK4 BK-18

T957-EK2 BK-18T951-EK1 BK-18

T953-EG1 BK-18T959-EG2 BK-18T954-EG3 BK-18T960-EG4 BK-18

INJECTORS

709-CL140 OR-18

709-CL140 OR-18

J764-CL141 BR-18

J764-CL141 BR-18

CONN TO LA-C5LEFT ARM HARNESS[LOC SH 1 H-11]

CONN TOOPR PRESENCE SW[LOC SH 1 F-11]

200-CL69 BK-14

200-CL69 BK-14

202-CL73 BK-18

202-CL73 BK-18

CONN TO P-C16PLATFORM HARN[LOC SH 1 E-3]

FORWARD HORN

322-EN12 GY-18

322-EN12 GY-18

322-EN12 GY-18

125-FP1 OR-14

125-FP1 OR-14

125-FP1 OR-14

125-FP1 OR-14

515-CL1 GY-12

515-CL1 GY-12

515-CL1 GY-12

C546-CL101 WH-16

C546-CL101 WH-16

C546-CL101 WH-16

L872-CL162 BU-14

L872-CL162 BU-14

L872-CL162 BU-14

125-CL11 OR-14

125-CL11 OR-14

125-CL10 OR-14

125-CL10 OR-14125-CL9 OR-16

125-CL9 OR-16

125-CL9 OR-16

125-CL3 OR-14

125-CL3 OR-14

C558-CL12 BU-14

C558-CL12 BU-14

C558-CL12 BU-14

C558-CL12 BU-14

516-CL2 GN-14

516-CL2 GN-14

516-CL2 GN-14

516-CL2 GN-14

517-CL18 BU-14

517-CL18 BU-14

517-CL18 BU-14

517-CL18 BU-14

A528-CL102 YL-16

A528-CL102 YL-16

A528-CL102 YL-16

A528-CL102 YL-16

200-CL123 BK-12

200-CL123 BK-12

200-CL123 BK-12

200-CL109 BK-14

200-EN67 BK-18

200-EN67 BK-18

115-EN70 RD-6

115-EN70 RD-6115-EN70 RD-6

115-EN70 RD-6

127-EN71 RD-10

127-EN71 RD-10

127-EN71 RD-10

195-EN57 YL-18

195-EN57 YL-18

375-EN83 BR-18

375-EN83 BR-18

310-EN19 PU-8

383-EN80 GN-18

383-EN80 GN-18

382-EN81 PK-18

382-EN81 PK-18

H451-EN40 GN-18

H451-EN40 GN-18

202-EN32 BK-18

202-EN32 BK-18

202-EN32 BK-18


[LOC SH 1 H-7]

308-FP2 YL-18

308-FP2 YL-18

506-FP69 PU-18

506-FP69 PU-18

F711-FP73 GN-18

K779-EN30 PU-18

382-EN81 PK-18

382-EN81 PK-18

115-EN62 RD-12115-EN62 RD-12

202-EN64 BK-14

202-EN64 BK-14

709-WN1 OR-18

C831-WN2 GN-18

F868-WN3 OR-18

F869-WN4 PK-18

J764-WN5 BR-18

J807-WN6 BK-18

J808-WN7 BK-18

709-WN1 OR-18C831-WN2 GN-18

J764-WN5 BR-18F869-WN4 PK-18

J807-WN6 BK-18

F868-WN3 OR-18

J808-WN7 BK-18

F868-EN79 OR-18

709-EN60 OR-18

709-EN60 OR-18

C831-EN63 GN-18

C831-EN63 GN-18

J764-EN66 BR-18

J764-EN66 BR-18

R997-F16 OR-18

R997-F16 OR-18

R997-F16 OR-18

R997-F16 OR-18R993-F17 BR-18

R993-F17 BR-18

R993-F17 BR-18

R993-F17 BR-18A499-F18 BU-18

A499-F18 BU-18

A499-F18 BU-18

A499-F18 BU-18

322-HN1 GY-18200-HN2 BK-18

200-EN67 BK-18

383-EN80 GN-18

383-EN80 GN-18

200-CL172 BK-18

614-CL171 PU-18

614-CL171 PU-18

200-CL172 BK-18

200-CL182 BK-18

200-CL182 BK-18

614-CL180 PU-18

614-CL180 PU-18

200-CL183 BK-18

200-CL183 BK-18

614-CL181 PU-18

614-CL181 PU-18

A315-CL34 WH-18A314-CL33 OR-18

E913-CL37 YL-18

200-CL183 BK-18

E912-CL36 PU-18

614-CL180 PU-18614-CL171 PU-18

614-CL181 PU-18

200-CL172 BK-18200-CL182 BK-18

202-CL151 BK-18

202-CL151 BK-18

202-CL151 BK-18

H451-EN40 GN-18

202-CL197 BK-18

202-CL197 BK-18

202-CL73 BK-18202-CL44 BK-18202-CL29 BK-18

202-CL198 BK-16

202-CL198 BK-16

202-CL197 BK-18

614-FP12 PU-18614-FP12 PU-18

614-FP12 PU-18

614-FP12 PU-18

614-CL4 PU-18

614-CL4 PU-18

130-FP25 RD-14

130-FP25 RD-14

130-FP25 RD-14

130-FP25 RD-14

103-CL152 YL-14

184-CL108 BU-14

184-CL108 BU-14

200-EN39 BK-18

643-CL25 GN-18

643-CL25 GN-18

643-CL25 GN-18

643-CL25 GN-18

202-CL26 BK-18

202-CL26 BK-18

J994-CL14 GY-18

J994-CL14 GY-18J994-CL15 GY-18

J994-CL15 GY-18

J994-CL13 GY-18

J994-CL13 GY-18

J994-CL13 GY-18

CONN TO P-C17PLATFORM HARN[LOC SH 1 D-3]

752-EH11 YL-18

751-EH13 GN-18

H714-EH4 OR-18

H713-EH5 PK-18

M929-EH10 WH-18

M928-EH9 BU-18

975-EH12 WH-18

975-EH14 WH-18

975-EH3 WH-18

975-EH2 WH-18

H802-EH8 GY-18

H802-EH7 GY-18

H714-EH4 OR-18

751-EH13 GN-18752-EH11 YL-18

H713-EH5 PK-18

M928-EH9 BU-18M929-EH10 WH-18

751-EH13 GN-18752-EH11 YL-18

H714-EH4 OR-18H713-EH5 PK-18

M928-EH9 BU-18M929-EH10 WH-18

975-EH12 WH-18

975-EH14 WH-18975-EH2 WH-18

975-EH3 WH-18

H802-EH8 GY-18

H802-EH7 GY-18

975-EH1 WH-18

975-EH1 WH-18

H802-EH6 GY-18H802-EH6 GY-18

ELECTRO-HYDRAULIC VALVE

E918-EH15 GN-18

E918-EH15 GN-18

E918-EH15 GN-18

H708-EH16 OR-18

H708-EH16 OR-18

H708-EH16 OR-18

CONN TO P-C8PLATFORM HARN[LOC SH 1 H-3]

UNUSED

LOCATION

608-FP44 GN-14

K779-EN30 PU-18

K779-EN30 PU-18

304-EN28 WH-12

N805-CL200 BU-18

N805-CL200 BU-18

N805-CL200 BU-18

N805-CL200 BU-18

N822-CL201 BR-18

N822-CL201 BR-18

N822-CL201 BR-18

N822-CL201 BR-18

N821-CL202 GN-18

N821-CL202 GN-18

N821-CL202 GN-18

N821-CL202 GN-18

200-CL203 BK-18

200-CL203 BK-18

614-CL204 PU-18

614-CL204 PU-18

202-CL205 BK-18

202-CL205 BK-18195-CL206 YL-18

195-CL206 YL-18

200-CL209 BK-18

200-CL209 BK-18

202-CL210 BK-18

202-CL210 BK-18

614-CL208 PU-18

614-CL208 PU-18

195-CL207 YL-18195-CL207 YL-18

N809-CL211 OR-18N809-CL211 OR-18

N809-CL211 OR-18

N809-CL211 OR-18N825-CL212 PK-18

N825-CL212 PK-18

N825-CL212 PK-18

N825-CL212 PK-18N824-CL213 PK-18

N824-CL213 PK-18

N824-CL213 PK-18

N824-CL213 PK-18

STD240-0101 ATCH

STD240-0101 ATCH

310-EN19 PU-8

180-CL62 GN-14

184-CL108 BU-14308-CL150 YL-18320-CL30 OR-16

607-CL121 PK-14608-CL122 GN-14

647-CL22 GN-16614-CL4 PU-18

129-CL19 BU-16125-CL3 OR-14

124-CL94 GN-14124-CL93 GN-14110-CL98 RD-16

105-CL24 RD-18

200-CL27 BK-18

103-CL152 YL-14

129-FP11 BU-16125-FP1 OR-14124-FP50 GN-14124-FP49 GN-14122-FP20 BU-16120-FP23 YL-16119-FP22 PK-16118-FP21 GY-16110-FP16 RD-16108-FP33 RD-18106-FP24 WH-18105-FP7 RD-18200-FP42 BK-18103-FP5 YL-14

158-FP65 BR-14158-FP66 BR-14159-FP67 BU-14159-FP68 BU-14180-FP13 GN-14184-FP51 BU-14308-FP2 YL-18320-FP47 OR-16506-FP69 PU-18507-FP70 WH-18529-FP71 WH-18530-FP72 OR-18607-FP43 PK-14608-FP44 GN-14647-FP38 GN-16614-FP12 PU-18

CONN TO AC-C4 HVAC HARN [LOC

SH 3 D-2]


[LOC SH 3 D-2]

MOTOR

BATMTR

SG

STARTER300-4415

AC COMPRESSOR CLUTCH

BK-14BK-14

HVAC ARC SUPPR106-8704

ABC

CAN A TERM RES 2134-2540

GND ENGM10 THD

NOTE A

SW HYDO BYP 2134-0404

EXCITATION RESISTOR238-9397

EN-C71552267

ABC

12

EN-C21552269

AB

AE-C31684999

AC REFRIG PRESS SW236-6923

12

AE-C21552269

12

AE-C11552269

123456789101112131415161718192021222324

EN-C121673693

25262728293031

105A

BKR CKT MAIN171-2212

BK-18BK-18

RLY MAIN PWR241-8367

NEGPOS

BOTTOM BATTERY3T-5760 "STD 750 CCA"

NEGPOS

TOP BATTERY9X-3404 "OPT 'X' 900 CCA"

12

FP-C83E3364

SOL PARK. BK252-47341

2

EN-C11552269

SOL L PUMP FWD269-4669

SOL L PUMP REV269-4669

SOL R PUMP REV269-4669

SOL R PUMP FWD269-4669

12

EN-C51552269

12

EN-C61552269

12

EN-C81552269

12

EN-C91552269

HORN FWD164-9425

+

-


12

EN-C101552269

EN-C219X1054

15243

FP-C59X1054

15243

87a87

85

8630

RLY START115-1615

87a87

85

8630

RLY HORN115-1615

1

2

3 4

5

6

7

8

CL-C422858569

10

12

CL-C111552273

3456

SW THROTTLE 106-0107

COMS1S2S3S4

12345

BK-18PK-18BU-18GN-18BR-18

SW LIGHTS 180-6615

OROPS CAB GND

NOTE A

12

RL-C111552269

12

RL-C91552269

RL-M

512

8418

0

12

RL-C51552269

12

RL-C61552269

12

RL-C71552269

12

RL-C81552269

FR RH LONG RNG 154-7986

OROPS ROOF GNDM10

NOTE A

LH RR FLOOD LAMP ATCH 240-0102

BK-16BK-16

FR LH LONG RNG 154-7986


12

F-C21552272

34

12

F-C31552269

12

F-C41552272

34

12

F-C51552269

12

F-C81552269

SOL MOT L269-4669

SOL MOT R269-4669

SIGNAL BSIGNAL AGROUNDVS

SNSR SP L TRACK183-4584

SIGNAL BSIGNAL AGROUNDVS

SNSR SP R TRACK183-4584

SW DISCONNECT7N-0718

FRAME GND 1M10 THD

NOTE A

BLK JCT PASS THRU172-4863

87a87

85

8630

RLY LTG 1115-1615

87a87

85

8630

RLY LTG 2115-1615

FP-C39X1054

15243

FP-C49X1054

15243

BUS BAR BLK TO BKR249-9020

CALSIGNALGROUNDPOWER

VI-18

YL-18BR-18WH-18

S AXIS HDL WN RIP307-4673

12

CL-C191552272

34

123456789101112

FP-C101977259

13141516171819

BUS BAR BLK TO RLY245-6034

ABCDEFGHJ

FP-C99W1951

FRAME GND 2M10 THD

NOTE A

B+

ALTERNATOR225-3145120A

G

D+ W

MOM

SW WIN DRIVE AWAY 249-9047

MOM

SW WN FREE SPOOL 249-9037

12

F-C72304011

12

F-C62304011

SOL WN REEL IN269-4669

SOL WN REEL OUT269-4669

12

WN-C31552269

12

WN-C41552269

1

2

3 4

5

6

7

8

CL-C122858569

10

1

2

3 4

5

6

7

8

CL-C1722858569

10

MOTOR

FR WSHR PUMP209-4481

MOTOR

LH DOOR WSHR PUMP209-4481

MOTOR

RH DOOR WSHR PUMP209-4481

1

2

Y-C11237615

1

2

Y-C21237615

1

2

Y-C31237615

MOTOR

RR WSHR PUMP209-4481

123456

Y-C53E3382

1

2

Y-C41237615

123456

F-C91552273

12

CL-C21552252

3456789101112

SNSR PRESS OVRD ANLG261-0420

BATTERYGROUNDSIGNAL

F-C122370227

123

MOM

MOM SW 4TH VALVE

249-90221

2

3 4

5

6

7

8

CL-C2622858569

10

123456789101112131415161718192021222324

CL-C202144208

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

123456789101112

CL-C223E5179

BUS BAR RLY BKR269-7647

123456789101112131415161718192021222324

CL-C212253854

25262728293031

12

E-C42388247

12

E-C32388247

12

E-C102304011

12

E-C82304011

E-C62304013

123

E-C52304013

123

E-C72370227

123

123456789101112131415161718192021222324

E-C12451042

25262728293031323334353637383940414243444546474849505152535455565758596061626364

12

CL-C103E3364

12

RL-C11552269

12

EN-C161552269 SOL HYSTAT OVRD

252-4734

123456789101112131415161718192021222324

EN-C42451042

25262728293031323334353637383940414243444546474849505152535455565758596061626364

- BATTERY (1)

INTK MAN PRESS. SIG

PUMP CAM SPEED SIGCRANK SPEED SIGFUEL RAIL PRESS. SIG

FUEL RAIL PRESS.PWR SPLYOIL PRESS. PWR SPLYINTK MAN AIR PRESS. PWR SPLYDIAGNOSTIC GROUNDSMART WASTEGATE GROUNDCOOL. TEMP SIG

INJ 2 DRVR RTNINJ 3 DRVR RTN

FUEL PUMP SOL RTNFUEL PUMP SOL SIGCAN A +CAN A -

DATALINK +DATALINK -

DIAG PWR SPLY (BAT)

SPEED SNSR SUPPLY

INJ 4 DRVR RTN

INTK MAN AIR TEMP SIG

F RAIL PRESS. GROUNDOIL PRESS. GROUNDINK MAN AIR PRESS. GROUNDCOMMON SNSR GROUND

+ BATTERY (3)+ BATTERY (4)

CAN A DATALINK + (J1939)

SW TO GROUND RTN

AIR INLET RSTR SW

KEY SW ON

START AID RELAY

ENGINE CONTROL286-3686

SMART WASTEGATE PWM SIG

ETHER SOL RTN

ETHER SOL (+)

USER DEFINED SHUTDOWN

SNSR - WATER IN FUEL

- BATTERY (2)- BATTERY (3)

- BATTERY (4)

+ BATTERY (1)+ BATTERY (2)

J1

J2

INJ 4 HIGHSIDE DRVR

OIL PRESS. SIGNAL

INJ 3 HIGHSIDE DRVRINJ 2 HIGHSIDE DRVRINJ 1 HIGHSIDE DRVR

INJ 1 DRVR RTN

GROUND

CAN A DATALINK - (J1939)

CAT DATALINK + (J1939)CAT DATALINK - (J1939)

INJECTOR 2

INJECTOR 1

INJECTOR 4

INJECTOR 3

12

EN-C111552269

12

AE-C43E3364

1234

EG-C11779649

1234

EK-C11779649

12

E-C121552272

34

12

E-C131552272

34

12

EN-C141761477

12

CL-C271552269

CL-C281552267

ABC

12

EN-C181552269

GLOW PLUG AS292-9880

12

CL-C241779654

34

12

CL-C251552272

34

12

CL-C161552252

3456789101112

1524

CL-C189X1054

3 87a87

85

8630

RLY BLOWER HIGH 115-1615

EN-C192733143

123 POWER

SIGNALGROUND

SNSR WATER IN FUEL313-1663

BK-18

BK-18BK-18

30 50

FUSE FORMAIN PWR RLY

UNSWITCHEDFUSE

SWITCHEDPOWER OUT

UNSWITCHEDPOWER OUT

BATTERY + IN

PRM275-0490

87 87a

85

86

30

MAIN PWRRELAY

SOL ETHER273-50701

2

EN-C261552269

SIGNALGROUNDVs

WH-18BR-18GN-18

SNSR PRESS. WN214-6863

12

EN-C252304011

12

EN-C281552269

SUPPRESSOR ARC106-8704

12

EN-C171552264

345678

12345678

WN-C13E3388

WN-C23E3370

ABC

ENGINE SPEED SNSR116-6680

BK-18BK-18

12

HN-C23E3364

12

HN-C11552269

1

2

3 4

5

6

7

8

CL-C1422858569

10

SW PARK. BK 190-8478

1

2

3 4

5

6

7

8

CL-C1322858569

10

SW IMP LOCKOUT 245-6033

12

CL-C31552252

3456789101112

12

CL-C91552253

3456789101112

12

F-C11552252

3456789101112

12

F-C111552254

3456789101112

SOL IMP OVRD304-1141

12

EH-C21552269

12

EH-C31552269

12

EH-C41552269

12

EH-C51552269

12

EH-C61552269

12

EH-C71552269

BK-18BK-18

SOL BLD ANGLE L304-1142

BK-18BK-18

SOL BLD ANGLE R304-1142

BK-18BK-18

SOL BLD RAISE304-1142

BK-18BK-18

SOL BLD LWR304-1142

BK-18BK-18

SOL BLD TILT L304-1143

BK-18BK-18

SOL BLD TILT R304-1143

12

EH-C91552269

123456789101112

EH-C13E5179

SIGNALGROUND

SNSR HYDO TEMP238-0112

SNDR FUEL LVL257-8924

BK-18BK-18

ALARM BKUP220-0230

BK-18BK-18

SIGNALGROUND

COOL TEMP238-0112

SIGNALGROUND

INTAKE MANF TEMP238-0112

SIGNALGROUND

CRANK SPEED 2X238-1020

SIGNALGROUND

CRANK SPEED 1X238-1020

INTAKE MANF PRESS274-6720

VsGROUNDSIGNAL

FUEL RAIL PRESS238-0118

VsGROUNDSIGNAL

OIL PRESS274-6721

VsGROUNDSIGNAL

FUEL PUMP SOL294-7375

BK-18BK-18

SMART MAST G294-7375

BK-18BK-18

PWR PRT178-7539

123456789101112131415161718192021222324

FP-C12253861

25262728293031

30A

BKR BLOWER

180-0613

15

A4M1

113-8491

10

FWD HORN

113-8490

10

KEY SWITCH

113-8490

20

LTG RLY 1

113-8492

15

A12C

113-8491

20

LTG RLY 2

113-8492

10

PWR PORT

113-8490

15

GR CONT 2

113-8491

20

AIR HEAT SEAT

113-8492

15

GR CONT 1

113-8491

15

HVAC

113-8491

30

BKR SPARE 30A

180-0613

15

GR CONT 3

113-8491

15

A5:M2

113-8491

FP-C7

1249636

A1A2

A3A4

A5A6

A7A8

A9

B1B2

B3B4

B5B6

B7B9

C1C2

C3C4

C5C6

C7C8

C9

D1D2

D3D4

D5D6

D7D8

D9

B8

FP-C6

1249636

A1A2

A3A4

A5A6

A7A8

A9

B1B2

B3B4

B5B6

B7B8

B9

C1C2

C3C4

C5C6

C7C8

C9

D1D2

D3D4

D5D6

D7D8

D920

SPARE 20A

113-8492

10

RADI

O113-8490

15

R WIPER

113-8491

10

DOME/RADIO

113-8490

15

FR W

IPER

113-8491

15

RR WIPER

113-8491

15

L WIPER

113-8491

15

SPARE 15A

113-8491

15

SPARE 15A

113-8491

20

SPARE 20A

113-8492

10

SPARE 10A

113-8490

10

SPARE 10A

113-8490

20

CONDNSR BKR 1

173-3175

20

CONDNSR BKR 2

173-3175

10

BACKLIGHT

113-8490

MED-HI

GND

B +

MEDLOW

HI

HVAC CONT PANEL 267-5239

A/CGNDBACKLIGHTING (+)BACKLIGHTING (-)B +SIGNAL

BK-18BK-18

SW INLET AIR276-4836

12

E-C151552269

12

E-C21552269

MOM

SW 4TH VALVE FLOAT 311-7069

1

2

3 4

5

6

7

8

CL-C3222858569

10

MOM

SW SEER 311-7070

1

2

3 4

5

6

7

8

CL-C3322858569

10

RH RR FLOOD-LAMP STD240-0102

BK-16BK-16

FR LH FLOOD LAMP ATCH 240-0102

FR RH FLOOD LAMP ATCH 240-0102

GROUND STRAP7G-1060

1

2 200-L32 BK-14

AG-C4111-7898

L-C123E-5179

C-C4130-6795



SocketPin

AG-C3130-6795







Plug

GroundConnection

325-AG135 PK-14


Wire Gauge


T



T


Receptacle


PressureSymbol

TemperatureSymbol

LevelSymbol

FlowSymbol









Symbols




Fuse(5 Amps)

5A

KE

NR

5711-0

1 V

OL

3 o

f 3

36

Pa

ge

, (D

ime

ns

ion

s:

48

in

ch

es

x 3

5 i

nc

he

s)


D3K, D4K and D5K





Volume 3 of 3: AccuGrade®


ACCUGRADE & ATTACHMENT WIRING

GPS RECEIVER

* SHOWN WITH LASER RECEIVERS MOUNTED

13

10

1231

26

3738 23

30

29

27

25

19

20

151497

636

8

1618

2

34

2217

21

35

11

3

32

33

244

28

5

1















Accugrade Laser System: KENR5966

Component Identifiers (CID¹)Module Identifier (MID²)Engine Control System

(MID No. 036)CID Component0001 Injector Cylinder #10002 Injector Cylinder #20003 Injector Cylinder #30004 Injector Cylinder #40005 Injector Cylinder #50006 Injector Cylinder #6




















Volume 3 - Resistor SpecificationsPart No. Component Description Resistance (Ohms)¹134-2540 Resistor: CAN B & CAN D 120¹ At room temperature unless otherwise noted.



CONN 1 F-1 1CONN 2 F-1 1CONN 5 H-13 2CONN 6 D-3 3CONN 7 D-3 3CONN 12 I-2 4CONN 13 G-3 5CONN 14 H-2 6CONN 16 A-15 7CONN 18 H-5 8CONN 19 H-5 8CONN 20 E-5 9CONN 21 F-5 9CONN 22 F-5 9CONN 27 B-14 9CONN 28 D-8 10CONN 29 D-8 10CONN 39 B-13 11CONN 40 Accugrade Service Connector G-13 12CONN 41 I-13 13CONN 42 B-11 14CONN 43 C-11 15CONN 44 D-11 16CONN 45 H-11 17CONN 46 I-11 17CONN 47 Accugrade Test Port B-10 18CONN 48 F-9,F-8,H-6 5CONN 49 G-9,E-8,H-6 5CONN 50 A-5 19CONN 51 Product Link Service Tool H-3 20




Alarm F-10 21Coil, MSS Excitation G-3 5Control, Ripper A-8 22Control, Winch C-8 22Diode, A/C E-1 1Display, GPS F-7 23Display, Laser CB420 H-12 24Display, Laser CD610 H-8 5Display, Product Link F-4 25Display, Product Link PL121SR H-4 26Light Bar, Left I-9 27Light Bar, Middle H-9 17Light Bar, Right H-9 28Mast, Electric (LH) C-9 29Mast, Electric (RH) C-9 30Module, Accugrade Power A-13 31Motor, Blower D-1 3Motor, Condenser #1 E-3 1Motor, Condenser #2 E-3 1Motor, Wiper (LH) I-15 32Motor, Wiper (RH) H-12 33Radio, GPS I-15 34Receiver, GPS (LH) D-9 29Receiver, GPS (RH) B-9 30Receiver, Laser (LH) C-10 29Receiver, Laser (RH) B-10 30Relay, HVAC Condenser #1 F-3 1Relay, HVAC Condenser #2 E-3 1Resistor, Blower Speed D-1 3Resistor, CAN B 1 F-9 35Resistor, CAN B 2 C-12 14Resistor, CAN D 1 F-9 35Resistor, CAN D 2 C-12 14Solenoids, Drive Away A-4 36Solenoids, Free Spool A-4 36Solenoids, Ripper (Lower) C-5 37Solenoids, Ripper (Raise) C-5 38Solenoids, Winch Brake A-4 36Switch, Thermostat D-1 3Valve, Water C-2 3Machine locations are repeated for components located close together.

Diagnostic Codes For The Accugrade Laser SystemDisplay (CB), Electronic Mast (EM), Laser Receiver (LR)

DiagnosticCode Description

Display Fault MessagesCB 1 Set Limits FaultCB 2 Lost Beam, Check SetupCB 3 Calibration Failure, Check SetupCB 4 Calibration Failure, Check Valve HardwareCB 5 Calibration Failure, RestartCB 6 Wrong Blade Motion, Check Valve HardwareCB 7 Calibration Failure, RestartCB 8 No Blade Movement, Check Valve HardwareCB 9 Calibration Failure, RestartCB 10 Set Limits Fault, RestartCB 11 Low Voltage, ServiceCB 12 System Hours Lost, ContinueCB 13 Valve Calibration Lost, RecalibrateCB 14 Memory Error, Recalibrate ValvesCB 15 Memory Fault, ServiceCB 16 Linked Mode Sensor Missing, Check EM and LR ConnectionsCB 17 CAN Network Failure, ServiceCB 18 CAN Network Failure, ServiceCB 19 CAN Network Failure, ServiceCB 20 CAN Controller Hardware Error, CheckCB 21 Remote AM Swith Failure, ServiceCB 22 VM Missing, ServiceCB 23 Unsupported Device, Cycle PowerCB 24 Duplicate Left/Right Device, ServiceCB 25 Elevation Limit Left, Check Bench SetupCB 26 Elevation Limit Right, Check Bench SetupCB 27 Internal Fault, Cycle PowerCB 28 Invalid Serial Number, ServiceCB 29 VM Intermittant, Check ConnectionCB 30 Duplicate Sensor Serial Number, ServiceCB 31 Recalibrate Linked Mode ElevationCB 32 ECM Disconnected, ServiceCB 33 VM Failure, ServiceCB 34 VM Failure, ServiceCB 35 VM Fault, ServiceCB 36 Left Laser Receiver MissingCB 40 Laser receiver hardware failure, ServiceCB 41 Control Latency, Cycle PowerCB 42 Control Latency, Cycle PowerCB 43 Laser Interference, Check Laser SetupCB 44 Laser Interference, Check Laser SetupCB 46 Slope ratio out of limitsCB 47 Sensor Missing, Check Harness ConnectionsCB 48 Invalid PasswordCB 49 Password ExpiredCB 50 Serial Number Fault, ServiceCB 52 Sensor not Supported, ReconfigureCB 56 Reference Target Not Found, ServiceCB 57 Password ExpiredCB 61 Service Agreement ExpiredCB 62 VM Fault, ServiceCB 63 Calibration Fault, Check Setup

Laser Receiver Fault MessagesLR 0 Communication Fault, ServiceLR 1 Memory Fault, ServiceLR 2 Memory Fault, ServiceLR 3 Serial Number Format Fault, ServiceLR 4 Serial Number Format Fault, ServiceLR 5 Serial Number Format Fault, ServiceLR 6 Flash Program Fault, RetryLR 20 End of Travel, Check SetupLR 21 Check ConnectionLR 148 Elevation Limit, Check Bench Setup

Electric Mast Fault MessagesEM 1 Internal Failure, ServiceEM 2 Limit Switch Failure, ServiceEM 15 Motor/Encoder Fault, ServiceEM 21 Elevation Fault, Verify BenchEM 23 Memory Fault, ServiceEM 24 Memory Fault, ServiceEM 25 Memory Fault, ServiceEM 26 Memory Fault, ServiceEM 29 Internal Fault, ServiceEM 30 Motor/Encoder Fault, ServiceEM 31 Memory Fault, ServiceEM 32 Check Connection, Check Harness Connection

Component Identifiers (CID¹)Module Identifier (MID²)

Accugrade Laser SystemImplement ECM (MID No. 114)

CID-FMI Component168 - 03 Electrical System Voltage Above Normal168 - 04 Electrical System Voltage Below Normal248 - 02 Invalid Cat Data Link Data248 - 09 Cat Data Link Not Communicating248 - 12 Cat Data Link Malfunction262 - 03 5 Volt Sensor Power Supply Voltage Above Normal262 - 04 5 Volt Sensor Power Supply Voltage Below Normal497 - 3 Tilt Right Solenoid Shorted High497 - 5 Tilt Right Solenoid Open Circuit497 - 6 Tilt Right Solenoid Current Above Normal498 - 3 Tilt Left Solenoid Shorted High498 - 5 Tilt Left Solenoid Open Circuit498 - 6 Tilt Left Solenoid Current Above Normal874 - 3 Mode Select Switch Open/Shorted High874 - 4 Mode Select Switch Short to Ground875 - 3 Manual Select Switch Open/Shorted High875 - 4 Manual Select Switch Short to Ground1197 - 3 Blade Lower Solenoid Shorted High1197 - 5 Blade Lower Solenoid Open Circuit1197 - 6 Blade Lower Solenoid Current Above Normal1198 - 3 Blade Raise Solenoid Shorted High1198 - 5 Blade Raise Solenoid Open Circuit1198 - 6 Blade Raise Solenoid Current Above Normal2114 - 3 Blade Control Handle Trigger Switch Open/Shorted High2114 - 4 Blade Control Handle Trigger Switch Short to Ground2233 - 0 Blade Lower Pilot Pressure Data Above Normal2233 - 1 Blade Lower Pilot Pressure Data Below Normal2233 - 3 Blade Lower Pilot Pressure Voltage Above Normal2233 - 4 Blade Lower Pilot Pressure Voltage Below Normal2234 - 3 Hydraulic Pump Boost Pressure Solenoid Shorted High2234 - 5 Hydraulic Pump Boost Pressure Solenoid Open Circuit2234 - 6 Hydraulic Pump Boost Pressure Solenoid Current Above Normal2235 - 3 Counterbalance Valve Bypass Solenoid Shorted High2235 - 5 Counterbalance Valve Bypass Solenoid Open Circuit2235 - 6 Counterbalance Valve Bypass Solenoid Current Above Normal

2324 - 3 Voltage of the solenoid circuit is above normal for the solenoid valve (2) for the counterbalance valve.

2324 - 5 An open in the circuit exists for the solenoid valve (2) for the counterbalance valve.

2324 - 6 There is a short to ground in the solenoid circuit for the solenoid valve (2) for the counterbalance valve.

¹ The is a diagnostic code that indicates which circuit is faulty.

² The MID is a diagnostic code that indicates which electronic control modulediagnosed the fault.

KE

NR

5711-0

1 V

OL

3 o

f 3

36

Pa

ge

, C

olo

r 2

, (D

ime

ns

ion

s:

48

in

ch

es

x 3

5 i

nc

he

s)



A

B

C

D

E

F

G

H

I

A

B

C

D

E

F

G

H

I

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1

15 14 13 12 11 10 9 8 7 6 5 4 3 2 1






RS-232 DATA LINK.

CAN DATA LINK D.


CAN DATA LINK B.


WINCH CONTROL CIRCUIT.ABBREV COLORRD REDWH WHITEOR ORANGEYL YELLOWPK PINKBK BLACKGY GRAYPU PURPLEBR BROWNGN GREENBU BLUE

COLOR ABBREVIATIONS

SYMBOL DESCRIPTION


CIRCUIT CONNECTED


ELECTRICAL CONNECTION TO MACHINE STRUCTUREINTERNAL ELECTRICAL CONNECTION TO SURFACE OF COMPONENT

CONNECTOR


CIRCUIT CONNECTED

SPLICE


CONN 16

CONN 27

CONN 39

CONN 42CONN 47

CONN 43

CONN 44

CONN 28

CONN 29

CONN 50

CONN 48

CONN 48

CONN 48

CONN 49

CONN 45

CONN 46

CONN 5

CONN 40

CONN 41

CONN 49

CONN 49

CONN 14

CONN 51

CONN 18

CONN 22

CONN 21

CONN 20

CONN 7

CONN 1

CONN 6

CONN 2

CONN 19

CONN 13

CONN 12

202-MR2 BK-18

T901-MR16 YL-18T902-MR7 PK-18

308-MR15 YL-18

308-MR15 YL-18

T901-MR16 YL-18T902-MR7 PK-18

F711-MR6 GN-18

F711-MR6 GN-18

F712-MR17 GY-18

F712-MR17 GY-18

202-MR2 BK-18

MSS (ATCH)

NOTE F

200-LW1 BK-16 200-LW1 BK-16

524-LW3 BU-16 524-LW3 BU-16

120-LW4 YL-16

120-LW4 YL-16

523-LW2 BR-16523-LW2 BR-16

200-RW1 BK-16

200-RW1 BK-16

526-RW2 YL-16

526-RW2 YL-16

527-RW3 GN-16

527-RW3 GN-16122-RW4 BU-16

122-RW4 BU-16

LH WIPER

PRODUCT LINK PL300SR (ATCH)

127-GW1 RD-18

127-GW1 RD-18

200-GW2 BK-18

200-GW2 BK-18

195-GW3 YL-18

195-GW3 YL-18

403-GW4 GN-18

403-GW4 GN-18

892-GW5 BR-18

892-GW5 BR-18

893-GW6 GN-18

893-GW6 GN-18

F711-GW7 GN-18

F711-GW7 GN-18

F712-GW8 GY-18

F712-GW8 GY-18

N957-GW9 PK-18

N957-GW9 PK-18

N960-GW11 OR-18N960-GW11 OR-18

N970-GW13 YL-18

N970-GW13 YL-18

N973-GW14 BR-18

N973-GW14 BR-18

N979-GW15 GN-18

N979-GW15 GN-18

184-GR1 BU-14

184-GR1 BU-14

T744-GR2 WH-14

T744-GR2 WH-14

K960-GR5 PK-18

K960-GR5 PK-18

N957-GR6 PK-18 N957-GR6 PK-18N960-GR7 OR-18

N960-GR7 OR-18K961-GR8 GN-18

K961-GR8 GN-18

CONN TO C-C22 EROPS CSL HARN

OR CL-C22OROPS CSL HARN

[C-C22 LOC SH 1 H-14][CL-C22 LOC SH 2 H-11]

184-GA44 BU-18184-GA44 BU-18

184-GA45 BU-18

184-GA45 BU-18

184-GA46 BU-18

184-GA46 BU-18

T744-GA47 WH-18

T744-GA47 WH-18

T744-GA48 WH-18

T744-GA48 WH-18

T744-GA49 WH-18

T744-GA49 WH-18

E752-GA50 YL-18

E752-GA50 YL-18

E752-GA51 YL-18

E752-GA51 YL-18

E752-GA52 YL-18

E752-GA52 YL-18

E753-GA53 WH-18

E753-GA53 WH-18

E753-GA54 WH-18

E753-GA54 WH-18

E753-GA55 WH-18

E753-GA55 WH-18

184-GC1 BU-14184-GC1 BU-14

ACCUGRADE DASH (ATCH)

110-GC2 RD-16

110-GC2 RD-16

ACCUGRADE CONSOLE

184-GC6 BU-14

184-GC6 BU-14

184-GC5 BU-14

184-GC5 BU-14

T744-GC7 WH-14

T744-GC7 WH-14

T744-GC10 WH-14

T744-GC10 WH-14

K960-GC14 PK-18

K960-GC14 PK-18

K960-GC13 PK-18

K960-GC13 PK-18

K960-GC12 PK-18

K960-GC12 PK-18

K961-GC15 GN-18

K961-GC15 GN-18

K961-GC17 GN-18

K961-GC17 GN-18

K961-GC16 GN-18

K961-GC16 GN-18

L856-GC18 YL-18

L856-GC18 YL-18

L856-GC20 YL-18

L856-GC20 YL-18L856-GC19 YL-18L856-GC19 YL-18

L857-GC21 GN-18

L857-GC21 GN-18

L857-GC23 GN-18

L857-GC23 GN-18

L857-GC22 GN-18L857-GC22 GN-18

N957-GC28 PK-18

N957-GC28 PK-18

N957-GC28 PK-18N958-GC29 PK-18

N958-GC29 PK-18

N958-GC29 PK-18N961-GC30 OR-18

N961-GC30 OR-18

N961-GC30 OR-18

N960-GC31 OR-18

N960-GC31 OR-18

N960-GC31 OR-18

N976-GC32 PU-18

N976-GC32 PU-18

N976-GC32 PU-18N967-GC33 GY-18

N967-GC33 GY-18

N967-GC33 GY-18

110-GA1 RD-16184-GA3 BU-14

184-GA3 BU-14 184-GA4 BU-18

K960-GA25 PK-18

K960-GA25 PK-18

K960-GA23 PK-18

K960-GA23 PK-18

K961-GA28 GN-18

K961-GA28 GN-18

K961-GA26 GN-18

K961-GA26 GN-18

L856-GA31 YL-18

L856-GA31 YL-18

L856-GA29 YL-18

L856-GA29 YL-18

L857-GA34 GN-18

L857-GA34 GN-18

L857-GA32 GN-18

L857-GA32 GN-18

J807-N1 BK-18

WINCH-RIPPER (ATCH)

195-N6 YL-16

195-N6 YL-16

J807-N1 BK-18

J807-N1 BK-18

195-N13 YL-18

202-N14 BK-18

202-N14 BK-18

202-N15 BK-18

202-N15 BK-18

709-N20 OR-18

N964-N21 BU-18

N964-N21 BU-18

N964-N21 BU-18

Y758-N22 PK-18

Y758-N22 PK-18

Y758-N22 PK-18

F711-N23 GN-18

F712-N24 GY-18

F869-N25 PK-18

F869-N25 PK-18

F869-N25 PK-18

F868-N26 OR-18

F868-N26 OR-18

F868-N26 OR-18

F870-N27 BU-18

J808-N28 BK-18

J808-N28 BK-18

J808-N28 BK-18

J809-N29 BK-18

F870-N27 BU-18

F870-N27 BU-18

J809-N29 BK-18

J809-N29 BK-18

J813-N30 BK-18

J813-N30 BK-18

J813-N30 BK-18

U717-N31 OR-18

U717-N31 OR-18

U717-N31 OR-18

H708-N32 OR-18

H708-N32 OR-18

H708-N32 OR-18

P730-N33 GN-18

P730-N33 GN-18

P730-N33 GN-18

WINCH AS.WINCH-CASE

U717-FN3 OR-18J813-FN4 BK-18J809-FN2 BK-18

F870-FN1 BU-18

P730-FN5 GN-18H708-FN6 OR-18

195-N13 YL-18

Y758-N40 PK-18

Y758-N40 PK-18

195-N34 YL-18

195-N34 YL-18

N812-N35 GN-18

N812-N35 GN-18

N812-N35 GN-18

F711-N23 GN-18

F712-N24 GY-18

F712-N37 GY-18

F712-N36 GY-18

F712-N36 GY-18

F711-N39 GN-18

F711-N39 GN-18

F711-N38 GN-18

F711-N38 GN-18

202-N41 BK-18

202-N41 BK-18

709-N20 OR-18

709-N42 OR-16

709-N42 OR-16

709-N43 OR-18

709-N43 OR-18

J921-N44 PK-18

J921-N44 PK-18

J921-N44 PK-18

J922-N45 GY-18

J922-N45 GY-18

J922-N45 GY-18

J914-N47 PU-18

J914-N47 PU-18

J913-N46 GN-18

J913-N46 GN-18

J914-N47 PU-18J913-N46 GN-18

PRODUCT LINK PL121SR (ATCH)

U717-FN3 OR-18

J813-FN4 BK-18

P730-FN5 GN-18

J809-FN2 BK-18F870-FN1 BU-18

H708-FN6 OR-18

CONN TO PRODUCT LINKSERVICE TOOL

N979-PL1 GN-18

N979-PL1 GN-18

N960-PL2 OR-18

N960-PL2 OR-18

N957-PL3 PK-18

N957-PL3 PK-18

F712-N37 GY-18

CONDENSER GP (ATCH)

521-W3 YL-16521-W4 YL-16

200-W2 BK-16C557-W5 OR-12

158-W8 BR-12

200-W10 BK-14

200-W11 BK-14

521-W12 YL-18

C556-W6 BU-12

159-W9 BU-12

C556-W6 BU-12

200-W7 BK-14

521-W12 YL-18

158-W8 BR-12200-W10 BK-14

159-W9 BU-12

200-W11 BK-14

200-W13 BK-14

521-W14 YL-16

HVAC BOX

200-W1 BK-16521-W4 YL-16C557-W5 OR-12


[LOC SH 1 C-3]

184-GA4 BU-18

T744-GA13 WH-14

AIR CONDITIONING

CONN TO P-C5PLATFORM HARN[LOC SH 1 D-3]

CONN TO P-C4PLATFORM HARN[LOC SH 1 C-3]

CONN TO P-C13PLATFORM HARN[LOC SH 1 I-3]

CONN TO R-C15ROOF-EROPS HARN[LOC SH 1 G-15]

CONN TO R-C14ROOF-EROPS HARN[LOC SH 1 G-15]

110-GC2 RD-16

CONN TO P-C12PLATFORM HARN[LOC SH 1 I-3]

RIPPER/4TH VALVE

NOTE F

CONN TO C-C15CONSOLE-EROPS HARN[LOC SH 1 I-11]

CONN TO C-C23CONSOLE-EROPS HARN

[LOC SH 1 A-8]

127-PL4 RD-18200-PL5 BK-18195-PL6 YL-18403-PL7 GN-18

N957-PL10 PK-18

N957-PL10 PK-18

N960-PL9 OR-18

N960-PL9 OR-18

N979-PL8 GN-18N979-PL8 GN-18

N970-PL11 YL-18N973-PL12 BR-18

N957-PL13 PK-18

N957-PL13 PK-18N973-PL12 BR-18N970-PL11 YL-18

403-PL7 GN-18195-PL6 YL-18200-PL5 BK-18127-PL4 RD-18

N973-PL12 BR-18N970-PL11 YL-18

403-PL7 GN-18

195-PL6 YL-18200-PL5 BK-18

127-PL4 RD-18

N979-PL14 GN-18

N979-PL14 GN-18

N960-PL15 OR-18

N960-PL15 OR-18

T744-GC35 WH-18

K960-GC24 PK-18

K960-GC24 PK-18

K961-GC25 GN-18

K961-GC25 GN-18

T744-GC3 WH-14

T744-GC3 WH-14L872-GC4 BU-18

L872-GC4 BU-18

CONN TO FC-C8DASH HARNESS

[LOC SH 1 D-9]

T744-GC35 WH-18

K961-GC43 GN-18K961-GC44 GN-18

K961-GC45 GN-18

K961-GC45 GN-18

K960-GC40 PK-18K960-GC41 PK-18

K960-GC42 PK-18

K960-GC42 PK-18

184-GC37 BU-18

184-GC37 BU-18

T744-GC46 WH-18

T744-GC46 WH-18

L872-GC4 BU-18

ACCUGRADESERVICECONNECTOR

127-GW17 RD-18127-GW16 RD-18

127-GW16 RD-18

403-GW18 GN-18403-GW18 GN-18

200-GW20 BK-18

200-GW20 BK-18 200-GW21 BK-18

195-GW23 YL-18195-GW22 YL-18

195-GW22 YL-18 403-GW19 GN-18

CONN TO P-C7PLATFORM HARN[LOC SH 1 C-3]

E752-GA59 YL-18

184-GA35 BU-18

892-GC8 BR-18

892-GC8 BR-18892-GC8 BR-18

893-GC9 GN-18

893-GC9 GN-18893-GC9 GN-18 893-GA68 GN-18

ACCUGRADE CD610LASER DISPLAY (ATCH)

110-GV1 RD-16

110-GV1 RD-16

T744-GV2 WH-18

K961-GV5 GN-18

K961-GV5 GN-18

L856-GV6 YL-18

L856-GV6 YL-18

L857-GV7 GN-18

L857-GV7 GN-18E752-GV8 YL-18

E752-GV8 YL-18

E753-GV9 WH-18

E753-GV9 WH-18

T744-GV10 WH-18

K960-GV11 PK-18

K960-GV11 PK-18

C218-GV13 BK-18A106-GV12 YL-18

T744-GV10 WH-18

110-GV1 RD-16

K961-GV5 GN-18L856-GV6 YL-18L857-GV7 GN-18

E752-GV8 YL-18E753-GV9 WH-18K960-GV11 PK-18

A106-GV12 YL-18C218-GV13 BK-18

T744-GV2 WH-18

T744-GV15 WH-16

T744-GV15 WH-16

C218-GV13 BK-18A106-GV12 YL-18

184-GV18 BU-18

184-GV18 BU-18

184-GV18 BU-18

CONN TO GA-C9ACCUGRADE DASH HARN

[LOC SH 3 F-9]

CONN TO GA-C10ACCUGRADE DASH HARN

[LOC SH 3 G-9]

893-GV20 GN-18

893-GV20 GN-18

893-GV20 GN-18

892-GV21 BR-18

892-GV21 BR-18

892-GV21 BR-18

K960-GA64 PK-18

K960-GA64 PK-18

K961-GA65 GN-18

K961-GA65 GN-18

L856-GA67 YL-18

L856-GA67 YL-18

L857-GA69 GN-18

L857-GA69 GN-18

N976-GA41 PU-18

N976-GA41 PU-18

N976-GA41 PU-18

N967-GA40 GY-18

N967-GA40 GY-18

N967-GA40 GY-18

N961-GA39 OR-18

N961-GA39 OR-18

N961-GA39 OR-18

N957-GA37 PK-18

N957-GA37 PK-18

N957-GA37 PK-18

110-GA1 RD-16

110-GA1 RD-16

184-GA35 BU-18

184-GA35 BU-18

892-GA66 BR-18

892-GA66 BR-18

893-GA68 GN-18

893-GA68 GN-18

A106-GA61 YL-18

A106-GA61 YL-18

E752-GA59 YL-18

E752-GA59 YL-18

C218-GA62 BK-18

C218-GA62 BK-18

E753-GA60 WH-18

E753-GA60 WH-18

E753-GA60 WH-18

E753-GA60 WH-18

T744-GA63 WH-16

T744-GA63 WH-16

T744-GA63 WH-16

T744-GA63 WH-16

N958-GA38 PK-18

N958-GA38 PK-18

N958-GA38 PK-18

N960-GA43 PK-18

N960-GA43 PK-18

N960-GA43 PK-18

ACCUGRADE PM400

200-GP1 BK-14

200-GP2 BK-14200-GP3 BK-14

200-GP1 BK-14

200-GP2 BK-14

200-GP3 BK-14

A101-GP4 GN-14

A101-GP4 GN-14

184-GP5 BU-14

184-GP5 BU-14184-GP5 BU-14

L872-GP6 BU-14

L872-GP6 BU-14L872-GP6 BU-14

T744-GP7 WH-14

T744-GP7 WH-14 T744-GP7 WH-14

L873-GP8 GY-14L873-GP8 GY-14

L873-GP8 GY-14

T745-GP9 YL-14

T745-GP9 YL-14T745-GP9 YL-14

CONN TO P-C15PLATFORM HARN[LOC SH 1 A-3]

A101-GP4 GN-14

200-GP12 BK-18

200-GP12 BK-18

200-GP10 BK-18

200-GP10 BK-18

ACCUGRADE FRONT

L872-GF1 BU-14K960-GF2 PK-18K961-GF3 GN-18T744-GF4 WH-14T745-GF5 YL-14L873-GF6 GY-14L856-GF7 YL-18L857-GF8 GN-18

L872-LH1 BU-14

L872-LH1 BU-14

K960-LH2 PK-18K960-LH2 PK-18

K961-LH3 GN-18K961-LH3 GN-18

T744-LH4 WH-14 T744-LH4 WH-14T745-LH5 YL-14 T745-LH5 YL-14L873-LH6 GY-14 L873-LH6 GY-14L856-LH7 YL-18 L856-LH7 YL-18L857-LH8 GN-18 L857-LH8 GN-18

L872-RH1 BU-14

L872-RH1 BU-14

T744-RH9 WH-14

T744-RH9 WH-14

K960-RH2 PK-18K960-RH2 PK-18

K961-RH3 GN-18K961-RH3 GN-18

T744-RH4 WH-14 T744-RH4 WH-14T745-RH5 YL-14L873-RH6 GY-14

L856-RH7 YL-18 L856-RH7 YL-18L857-RH8 GN-18 L857-RH8 GN-18

L872-AH1 BU-14L872-AH1 BU-14

K960-AH2 PK-18 K960-AH2 PK-18K961-AH3 GN-18 K961-AH3 GN-18

T744-AH4 WH-14

L872-GH1 BU-14

L872-GH1 BU-14

K960-GH2 PK-18

K960-GH2 PK-18

K961-GH3 GN-18

K961-GH3 GN-18

T744-GH4 WH-14

T744-GH4 WH-14

T745-GH5 YL-14

T745-GH5 YL-14

L873-GH6 GY-14

L873-GH6 GY-14

L856-GH7 YL-18

L856-GH7 YL-18

ACCUGRADE HOOD

L857-GH8 GN-18 L857-GH8 GN-18

L872-GH10 BU-14

L872-GH10 BU-14

L872-GH11 BU-14

L872-GH11 BU-14

L872-GH9 BU-14

L872-GH9 BU-14

K960-GH12 PK-18K960-GH12 PK-18

K960-GH13 PK-18

K960-GH13 PK-18

K960-GH13 PK-18

K960-GH14 PK-18

K960-GH14 PK-18

K960-GH14 PK-18

K960-GH15 PK-18

K960-GH15 PK-18

K960-GH15 PK-18

K961-GH16 GN-18

K961-GH16 GN-18K961-GH17 GN-18

K961-GH17 GN-18

K961-GH17 GN-18

K961-GH18 GN-18

K961-GH18 GN-18

K961-GH18 GN-18

K961-GH19 GN-18

K961-GH19 GN-18

L856-GH28 YL-18

L856-GH28 YL-18

L856-GH29 YL-18

L856-GH29 YL-18

L856-GH30 YL-18

L856-GH30 YL-18

L857-GH31 GN-18

L857-GH31 GN-18

L857-GH32 GN-18

L857-GH32 GN-18

L857-GH33 GN-18

L857-GH33 GN-18

T744-GH20 WH-14

T744-GH20 WH-14

T744-GH21 WH-14

T744-GH21 WH-14T744-GH22 WH-14

T744-GH22 WH-14T745-GH24 YL-14

T745-GH24 YL-14T745-GH25 YL-14

T745-GH25 YL-14

T744-GH23 WH-14

L873-GH26 GY-14

L873-GH26 GY-14L873-GH27 GY-14

L873-GH27 GY-14

K960-GH34 PK-18

K960-GH35 PK-18

K961-GH36 GN-18

K961-GH37 GN-18

L856-GH38 YL-18

L857-GH39 GN-18

L872-GH10 BU-14L872-GH11 BU-14L872-GH9 BU-14

K961-GH19 GN-18

L856-GH29 YL-18L856-GH30 YL-18L857-GH32 GN-18L857-GH33 GN-18

T744-GH20 WH-14T744-GH21 WH-14T744-GH22 WH-14

T745-GH24 YL-14T745-GH25 YL-14

T744-GH23 WH-14

T744-GH23 WH-14

L873-GH26 GY-14L873-GH27 GY-14

CONN TO P-C14PLATFORM HARN[LOC SH 1 H-3]

ACCUGRADE (ATCH)

T744-GJ23 WH-18

T744-GJ10 WH-18T744-GJ9 WH-18

T744-GJ15 WH-18

T744-GJ14 WH-18

E752-GJ24 YL-18E753-GJ22 WH-18

K961-GJ1 GN-18

K961-GJ1 GN-18K960-GJ2 PK-18

K960-GJ2 PK-18

L856-GJ3 YL-18

L856-GJ3 YL-18L857-GJ4 GN-18

L857-GJ4 GN-18

N958-GJ5 PK-18

N958-GJ5 PK-18

N961-GJ6 OR-18

N961-GJ6 OR-18

110-GJ7 RD-16

110-GJ7 RD-16184-GJ8 BU-18

184-GJ8 BU-18

N976-GJ16 PU-18N976-GJ16 PU-18N967-GJ17 GY-18

N967-GJ17 GY-18

N960-GJ18 OR-18

N960-GJ18 OR-18

N957-GJ19 PK-18

N957-GJ19 PK-18

E753-GJ22 WH-18E752-GJ24 YL-18

T744-GJ13 WH-16

T744-GJ13 WH-16

ACCUGRADE CD700GPS DISPLAY

(ATCH)

ACCUGRADEROOF (ATCH)

RH WIPER

T745-RH5 YL-14L873-RH6 GY-14

CONN TO GV-C3ACCUGRADE LASER HARN

[LOC SH 3 H-6] OR

CONN TO GJ-C2ACCUGRADE GPS HARN

[LOC SH 3 F-8]

CONN TO GV-C2ACCUGRADE LASER HARN

[LOC SH 3 H-6]OR

CONN TO GJ-C3ACCUGRADE GPS HARN

[LOC SH 3 F-8]

CONN TO GA-9ACCRUGRADE DASH HARN

[LOC SH 3 F-9]

CONN TO GA-C10ACCRUGRADE DASH HARN

[LOC SH 3 G-9]


[LOC SH 1 B-3]

T744-AH4 WH-14

T744-GA13 WH-14

892-GA66 BR-18

200-AC14 BK-12

517-AC3 BU-14

522-AC1 WH-16

516-AC4 GN-14517-AC3 BU-14

200-AC2 BK-12

522-AC1 WH-16

200-AC10 BK-16

200-AC14 BK-12

522-AC1 WH-16

200-AC2 BK-12

516-AC4 GN-14

517-AC3 BU-14

516-AC4 GN-14

200-AC12 BK-16

579-AC8 BR-12

579-AC8 BR-12

579-AC8 BR-12

A528-AC13 YL-16

A528-AC13 YL-16

124-AC11 GN-16

124-AC11 GN-16

200-AC10 BK-16

515-AC6 GY-12

515-AC6 GY-12

515-AC6 GY-12

C568-AC5 WH-12

C568-AC5 WH-12

C568-AC5 WH-12

E752-GA59 YL-18

T744-GA13 WH-14

N961-GR11 PK-18

N961-GR11 PK-18N958-GR10 OR-18N958-GR10 OR-18

F711-GW7 GN-18

127-GW17 RD-18

403-GW19 GN-18

200-GW21 BK-18

195-GW23 YL-18

F712-GW8 GY-18

N979-GW15 GN-18N973-GW14 BR-18

N970-GW13 YL-18N960-GW11 OR-18

N957-GW9 PK-18

892-GW5 BR-18893-GW6 GN-18

N976-GJ16 PU-18

N967-GJ17 GY-18

N960-GJ18 OR-18

N957-GJ19 PK-18

T744-GJ14 WH-18T744-GJ15 WH-18

184-GJ8 BU-18

110-GJ7 RD-16

E752-GJ24 YL-18E753-GJ22 WH-18

T744-GJ10 WH-18T744-GJ9 WH-18

N961-GJ6 OR-18

N958-GJ5 PK-18

L857-GJ4 GN-18

L856-GJ3 YL-18

K960-GJ2 PK-18

K961-GJ1 GN-18

T744-GJ23 WH-18 521-W14 YL-16200-W13 BK-14

159-W9 BU-12

200-W1 BK-16

158-W8 BR-12

521-W3 YL-16

200-W2 BK-16200-W7 BK-14

200-W11 BK-14

C557-W5 OR-12

NOTE J

NOTE G, H

NOTE K

CONN TO C-C25 EROPS CSL HARN[SH 1 LOC I-14]

ORCONN TO CL-C25OROPS CSL HARN[SH 2 LOC I-14]

CONN TO C-C24 EROPS CSL HARN[SH 1 LOC I-14]

ORCONN TO CL-C24OROPS CSL HARN[SH 2 LOC I-14]

ACCUGRADE TEST PORT

EXCITER COIL206-5203

BKBK

12

MR-C31552269

MSS TORNADO ECM218-0404

KEYSWITCH ONGNDCAN DATA LINK +

EXCITER COIL RETURN

CAN DATA LINK -EXCITER COIL SIGNAL

12345678

12

MR-C41552264

345678

1234

LW-C13E3376

123456789101112131415161718192021222324

GW-C31607690

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

12345678

MR-C13E3388

WINCH CONTROL300-3631

BATTERY+ADDRESS IN

CAN A DATA LINK - (J1939)GROUND

10V SENSOR SUPPLYCAN A DATA LINK + (J1939)

ADDRESS OUT

DRIVE AWAY SOL RETURNREEL OUT SOL RETURN

FREE SPOOL SOL RETURNREEL IN SOL RETURN

REEL IN SOL SUPPLYFREE SPOOL SOL SUPPLY

DRIVE AWAY SOL SUPPLYREEL OUT SOL SUPPLY

CAN B-

CAN B+RXD #2TXD #2

TXD #1RXD #1

SBGND

GPS RADIO

ABCDEFGH

GR-C31678987

123456789101112

GC-C11552252

GA-C21552267

ABC

GA-C31552267

ABC

123456789101112

GA-C43E5179

12

GC-C31552252

3456789101112

SOL FREE SPOOL279-6529

SOL DRIVE AWAY279-6529

SOL WN BRAKE259-8194

123456

FN-C13E3382

12

N-C71552273

3456

12

FN-C21552269

12

FN-C31552269

12

FN-C41552269

123456789101112

N-C22304009

123456789101112

N-C92304009

12

GA-C51552264

345678

12345678

GC-C43E3388

123456789101112

GC-C23E5179

12

GR-C11552252

3456789101112

ABC

CAN B TERM RES 1134-2540

ABC

CAN D TERM RES 1134-2540

PL-C29X4813

ABC

RIPPER CONTROL300-3631

BATTERY+ADDRESS IN

CAN A DATA LINK - (J1939)GROUND

10V SENSOR SUPPLYCAN A DATA LINK + (J1939)

ADDRESS OUT

RIPPER LOWER CYL RETRACT RTN

RIPPER RAISE CYL EXTEND RTN

RIPPER RAISE CYL EXTEND SOL

RIPPER LOWER CYL RETRACT SOL

KEYSWITCH

LOGGER RXD

+ BATTERY

R-TERMTX

- BATTERY

CONT ELEK PL121SR263-9088

LOGGER GNDRXSIGNAL GNDDTRDCDLOGGER TXD

RELAY 2115-1615

RELAY 1115-1615

MOTOR

CONDENSER MOTOR 1304-3716

MOTOR

CONDENSER MOTOR 2304-3716

2 5

1

4

3

W-C29X1054

2 5

1

4

3

W-C39X1054

12

W-C41779646

12

W-C51779646

12

W-C11779649

34

12

W-C63E3364

AC DIODE106-8704

12

W-C71552269

12

N-C12312296

345678

12

N-C82312296

345678

12345678

N-C102312301

H

PB+

TMOTOR

LH DOOR WIPER MOT 261-7993

BKBRBUYL

12

LW-C22305008

34

12

RW-C22305008

34

123456789101112

PL-C13E5179

DISPLAY LASER CB420253-5371

SWITCHED PWR

CAN HIGHCAN LOWAWAKEGND

SWITCH 1SWITCH 2SWITCH 3SWITCH 4SWITCH 0SWITCH GND

SPAREAB

GC-C72532695

CDEF

H

PB+

T

MOTOR

RH DOOR WIPER MOT261-7992"4A NOM, 7A MAX"

BKGNRDYL

12 uH

0.47 uF

GND

1234

RW-C13E3376

12

N-C121552269

12

N-C111552269

12

N-C51552264

345678

ALARM167-8712

GC-C58T8736

ABCDEFGHJ

12

GA-C62305008

34

12

GA-C72305008

34

12

GA-C82305008

34

123456789101112

GW-C13E5179

123456789101112

GW-C21552252

12

GW-C41552269

12

PL-C43E3364

12

PL-C31552252

3456789101112

123456789101112131415161718192021222324

GV-C11471444

25262728293031323334353637383940414243444546474849505152535455565758596061626364656667686970

BATTERY +

DISPLAY LASER CD610282-8241

BATTERY -KEYSWITCHDIMMING

CDL +CDL -

CAN B-CAN D+CAN D-

COM 1 TXCOM 1 RXCOM 1 GND

CAN B+

ALARMALARM RET

123456789101112

GP-C13E5179

AWAKE RTN F

SW PWR 2 CSW RTN 1 BPM PWR 1 A

GROUND D

GROUND B+ BATTERY C

+ BATTERY A

AWAKE ESW RTN 2 D

GR CONT PM400226-9169

AB

GP-C23R9965

CDEFGH

AB

GP-C36D5257

CDEFGH

12

GF-C11552264

345678

12

GF-C21552264

345678

12345678

LH-C13E3388

123456789101112

RH-C11552252

1234

AH-C13E3376

12345678

GH-C13E3388

ABC

CAN B TERM RES 2134-2540

ABC

CAN D TERM RES 2134-2540

GH-C21552267

ABC

GH-C31552267

ABC

12

GH-C41552264

345678

123456789101112

GH-C53E5179

12

GH-C61552272

34

RS232-TXRS232-RXGNDPWR

WH

ORBKRD

LIGHT BAR LEFT286-9124


WH

ORBKRD

LIGHT BAR MID286-9124


WH

ORBKRD

LIGHT BAR RIGHT286-9124

RIPPER RAISE SOL304-1142

RIPPER LOWER SOL304-1142

RS-232 CTS 0

AWAKE RETURN

SWITCH INPUT 5RS-232 TXD 1RS-232 RXD 1

RS-232 S GND 2RS-232 RXD 2RS-232 TXD 2CAN LOW 1CAN HIGH 1

CAN LOW 0CAN HIGH 0

4S-232 S GND 1

SWITCH INPUT 2RADIO SWITCHRS-232 TXD 0RS-232 RXD 0

SWITCH GND

SWITCH INPUT 0SWITCH INPUT 3BATTERY +

GROUND

SWITCH INPUT 4

BATTERY +WAKE UPSWITCH INPUT 1SWITCH INPUT 6RCA LINE OUT HIGHRCA LINE OUT LOW

CAT DATA LINK +

DISPLAY GPS CD700244-1716

GROUND

RS-232 RTS 0CAN SHIELD

CAT DATA LINK -

AWAKERS-S32 S GND 0

GJ-C11805305

ABCDEFGHJKLMNPRSTUVWXYZAABBCCDDEEFFGGHHIIJJKKMMNNPPQQRR

PWR (+)TERMINATION CONT

CAN HIGHCAN LOW

PWR CONTPWR (-)

RH COILED CABLE 6 WIRE276-0764

ABCDEF

RD-20BU-20GN-20WH-20BR-20BK-20

ABCDEFGHIJ

RH-C22302566

RH MAST ELEC226-2334

ABCDEFGHIJ

ABCDEF

PWRNO TERM REQCAN HCAN LPWR ON REQPWRGNDPWRGNDPWRNCNC

PWRNO TERM REQCAN HCAN LPWR ON REQPWRGND

RD-14BU-20GN-20WH-20BR-20BK-14GY-14OR-14

RH COILED CABLE 10 WIRE231-0049

ABCDEFGHIJ

LH-C22302566

PWR (+)TERMINATION CONT

CAN HIGHCAN LOW

PWR CONTPWR (-)

LH COILED CABLE 6 WIRE276-0764

ABCDEF

RD-20BU-20GN-20WH-20BR-20BK-20

LH MAST ELEC226-2334

ABCDEFGHIJ

ABCDEF

PWRNO TERM REQCAN HCAN LPWR ON REQPWRGNDPWRGNDPWRNCNC

PWRNO TERM REQCAN HCAN LPWR ON REQPWRGND

RD-14BU-20GN-20WH-20BR-20BK-14GY-14OR-14

LH COILED CABLE 10 WIRE231-0049

ABCDEFGHIJ

AH-C22302566

BATTERY +

PRODUCT LINK CONTROL262-1421

BATTERY -

KEYSWITCH ON

CDL +CDL -

CAN A-

CAN A+

R-TERM

RS-232 PORT 1 - TXD

RS-232 PORT 1-RXDRS-232 PORT 1-DTR

RS-232 PORT 1-DCDRS-232 PORT 1-GND

MOTOR

BLOWER MOTOR277-7715

12

AC-C21779646

1

AC-C66T6505

THERMOSTAT SW3E-5464

THERM INTHERM OUT1

AC-C56T6505

1

AC-C86T6505

1

AC-C96T6505

1

AC-C106T6505

1234

AC-C41779649

1234

AC-C13E3376

1

AC-C116T6505

1

AC-C76T6505

12

AC-C31552272

34

LOW

MED

BLOWER SPEED RESIST282-3475

MED-HI

HI

MOTOR

B+CTRL SIG

GNDFEEDBACK SIG

WATER VALVE265-9620

12345678

N-C63E3388

12

GA-C101552254

3456789101112

12

GA-C91552252

3456789101112

123456789101112

GV-C23E5179

123456789101112

GV-C31907612

123456789101112

GJ-C23E5179

123456789101112

GJ-C31907613

RDBLGNWH

BK

GYOR

RDOR

BKBKBKBKBK

WHBLGYGN

BKBKORBK

RD

BKWHBLGYGN

RDBLGNWH

BK

GYOR

RDOR

BKBKBKBKBK

WHBLGYGN

BKBKORBK

RD

BKWHBLGYGN

GPS ONLY

CONNECT TO LH-C2LEFT BULKHEAD HARN

SH 3, LOC D-10

GPS ONLY

CONNECT TO RH-C2RIGHT BULKHEAD HARN

SH 3, LOC B-10

ABCDEFGHJKLMNPRS

ABCDEFGHIJ

LH COILED CABLE GPS254-9136 RS232 GND

PWR -CAN 2 LCAN 2 GNDCHASSISRS232 1 TXDPWR +BOOT MONITORRS232 1 RXDCAN 1 GNDCAN 1 LIDCAN 2 HCAN 1 HRS232 2 RXDRRS232 2 TXD

LH RECEIVER GPS291-1913

ABCDEFGHJKLMNPRS

ABCDEFGHIJ

1

RH COILED CABLE GPS254-9136 RS232 GND

PWR -CAN 2 LCAN 2 GNDCHASSISRS232 1 TXDPWR +BOOT MONITORRS232 1 RXDCAN 1 GNDCAN 1 LIDCAN 2 HCAN 1 HRS232 2 RXDRRS232 2 TXD

RH RECEIVER GPS291-1913

Documents

D3 K XL CAT.SIS ELECTRICO.pdf