Upload
others
View
7
Download
0
Embed Size (px)
Citation preview
Sinisa Bacalja Sworn Court Surveyor
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Address: Doverska 32 a, 21000Split, Croatia
CONDITION SURVEY
MORGAN KETCH 462
S/V “PLANKTON”
Marina Kaštela, Croatia Attending Surveyor: Ing. Siniša Bacalja 06.08.2014. Sworn Court Surveyor mag. ing. Ante Babarovic Marine surveyor Page 1
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Adress: Doverska 32 a, 21000Split, Croatia
CONTENT
1. Introduction
2. Boat description with general information
3. Inspection
4. Conclusion
5. Attachments
Page 2
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Adress: Doverska 32 a, 21000Split, Croatia
1. Introduction
THIS IS TO CERTIFY THAT:
at the request and on behalf mr. Doug Schindler as boat owner, condition survey was held
upon the sailing boat
MORGAN KETCH 462
S/V “PLANKTON”
registered under USA flag whilst boat was afloat and safely laying on cradle in Marina
Kaštela, Croatia, for the purpose of an examination and ascertaining her compatibility with
regulations applicable to the pleasure boats, check seaworthiness and issuing report as
detailed hereunder.
Page 3
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Adress: Doverska 32 a, 21000Split, Croatia
2. Boat description with general information
1. Vessel type: MORGAN KETCH 462
2. Name of boat: PLANKTON
3. Year of production: 1982
4. Flag USA
5. LOA 14, 20 m
6. Beam: 4, 10 m
7. Draft: 1, 60 m
8. Engine: PERKINS 4 – 154
9. Power: 62 HP
10. Sails: MAIN SAIL, FORE SAIL and GENOA SAIL
11. Cruising speed: 2500 rpm – 6.5 knots
12. Official number: 652441
13. Hull number: US – MRY27108M83A - 462
14. Place of production: Largo, Florida - USA
NOTE: The above vessel specification are taken from the Vessels Certificates founded on board: No measurements or calculations were made by surveyor / surveyors, unless otherwise noted.
3. Inspection Hull and superstructure
Hull is made from GRP, designed with longitudinal and transverse construction as sailing
boat with one engine and keel casted in GRP. Hull hardness test was carried out with
“Barcol” tester Qualitest. Random inspection was carried out with satisfactory result. Hull
hardness in average is above 30 Barcols what is satisfactory.
Page 4
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Adress: Doverska 32 a, 21000Split, Croatia
Hull moisture measurement was carried out two days after hauling. Day of survey was
sunny what enabled me to start after two days drying measuring hull moisture with
nondestructive electronic Moisture meter “Sovereign Marine” to locate & identify areas of
moisture absorption. On some spots where is thick layer of paint is showing alarm on
instrument. On spots where is just gelcoat readings on instrument are found in good order.
Hull was affected with osmosis. Osmosis is old, without new blisters and osmotic leaks.
Opinion of undersigned is that osmosis is not active any more. Probably boat was treated
for osmosis in the past. Hull Barcol hardnes test was performed and readings are
satisfactory. Hull fittings are visual inspected and found healthy. The vessel’s hull and deck
structures were inspected externally and internally (where accessible) and found to be in
good condition. Vertical sides are found in very good condition. New antifouling protection
should be applied. The underwater body did not show evidence of hard grounding,
stranding or similar damaging event. Boat have traditionally heavy rudder which have
slightly bigger clearance, but still within limit. Propeller shaft is found without clearance.
Propeller is found in good order. Zn anodes are found in good order. As fare it can be
ascertained from visual inspection and measurements hull is found in good condition.
Engine
Engine starts on first try and work normally. New engine (Perkins) is installed 1997.
Engine has 3588 running hours. Only visual inspection was carried out. Visual inspection is
satisfactory. Engine is clean and well maintained. Engine bilges are found in good order
and without oil leaks. In engine compartment is installed generator. Generator starts and
works normally under load. In engine compartment upper part are traced various cables,
unprofessionally secured.
Deck
Deck is made from GRP in non-slide execution. On deck are visible several minor stress
cracks. There is some wooden parts on boat deck which need regular maintenance, this is
only cosmetic issue. On deck several places elastic putty need to be replaced. On deck aft
Page 5
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Adress: Doverska 32 a, 21000Split, Croatia
part are situated flat solar panels. Solar panels are found in good condition. Structurally
deck is found in good order.
Cockpit
Cockpit is protected with Bimini and Sprayhood stainless steel constructions. Bimini and
Spray hood canvas are new. In cockpit are located two winches. Winches are found without
clearance. Gangway is stored in forward cabin. Gangway is found in good order. Gunwale
is found undamaged and crack free. In cockpit central part is installed skipper post.
Sails
Boat is equipped with Genoa sail, main sail and fore sail. Random portions were inspected.
Genoa sail and foresail are found in acceptable condition. Main sail need to be replaced.
Sails are safely stored in Lazy bags. Lazy bags are found in good condition.
Mast standing rigging and running rigging
Boat is equipped with two aluminum masts. Both masts have one spreader in the middle.
On forward mast are located two additional winches “Lewmar”, on forward boom are
located one winch “Lewmar” and on aft mast is located another winch “Lewmar”. Mast and
spreaders are found in good condition. On aft mast is situated radar and wind generator.
Standing rigging is found in good condition. Mast foundation and fittings on deck are crack
free. Genoa sail is of furling type. Furling device “Harken” is operational. Running rigging
is found in good order. Boat is equipped with additional storm sail. Storm sail is found in
good condition. Side stays are found without stress cracks. Side stays are found strong.
Fastenings
Boat is equipped with aluminum cleats. All are strong connected to deck and damage free.
Windows and port lights
Side windows are found in good order and leak free. Salon side windows are found in good
order. Deck windows (hatch windows) are found in good order. New elastic putty should
be applied. Aluminum hatches on deck need regular maintenance. Page 6
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Adress: Doverska 32 a, 21000Split, Croatia
Hand rails and stanchions
Hand rails and stanchions are all find in good order.
Shell openings and shell fittings
The condition of the sea valves and through-hull fittings is good. Hummer test was carried
out. The hose connections are double clipped with stainless steel clips.
Door
Door (boat entrance) is found in good order. Door can be locked against theft. Boat has
possibility to reach forward cabin and aft cabin from deck. Doors can be locked against
theft. Through wooden stairs is entrance to accommodation. Below wooden stairs are
located three “Mastervolt” batteries. On aft port side are located skipper post equipped
VHF Station “ICOM IC – M700PRO”, Signal instrument SCS PTC LINE, “Standard
Horizon” AIS GX 2000, RAYTHEON GPS NAV LORAN, Multi instrument and
RAYTHEON PILOT Raypilot 650. Behind skipper post is situated main switch board
equipped with generator switch, several switches and battery charger/inverter switch. Boat
is equipped with adequate number of nautical charts.
Accommodation
On forward part is situated cabin with matrimonial bed and own sanitary facilities. Toilet is
mechanical type. On salon starboard side is situated U – shaped sofa with wooden table. On
opposite side is located another sofa. Under salon is located water tank and fuel tank. On
salon aft starboard side is located galley. On salon aft port side there is alleyway to aft
cabin. In alleyway is located working table with tools. On aft part are located Owners cabin
with matrimonial bed and access to own sanitary facilities.
Davits, boarding ladders, accesses
Boat is equipped with stainless steel davits. On aft part are located bathing ladders and
wooden platform. Ladders and aft platform are strong.
Page 7
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Adress: Doverska 32 a, 21000Split, Croatia
Bilge and general pumping installations
Bilge is equipped with adequate number of bilge pumps. Boat has two automatic and two
manual bilge pumps.
Fuel installations
Fuel installation is found in accordance to regulations. Boat is equipped with one diesel
tank.
Water installations
Water installation is found in accordance to regulations. Boat is equipped with two water
tanks.
Gas installations
LPG installation is not installed with appropriate regulations. LPG bottles are located on
deck aft part. LPG bottles need to be secured in aft storage with vent to atmosphere.
Ventilation
Boat has only natural ventilation.
Electric installation
Electric installation needs attention. On several places and especially in engine room cables
are naked and need to be safely terminated. On several places are found obsolete wires.
Boat is equipped with three batteries. Batteries are found in good order and without
corroded contacts.
Page 8
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Adress: Doverska 32 a, 21000Split, Croatia
Life saving and fire protection equipment
Life saving equipment consists of:
- Life jackets
- First AID kit
- EPIRB (in service date)
- LIFESLING
- Horseshoe safety ring
- Life raft “Winslow” for 6 persons (in service date)
- Man overboard equipment
- Pyrotechnic is in service date
- Fire extinguishers are out of service date
- SPOT Satellite Personal Tracker
- Dinghy 3.50 m and two outboard engines “Mercury” 4 HP and “Honda” 2.5 HP
Navigational equipment
Navigation equipment consists of: steering wheel, AUTOHELM “Wind”, compass
“Ritchie”, RAYTHEON RADAR/GPS/PLOTTER “Pathfinder” SL70, RAYTHEON
Autopilot “Raypilot” 65, GPS GARMIN “GPSmap 478, VHF “Standard Horizon –
RAM3”, DEPTH “Standard Horizon”, engine indicators (oil pressure, battery volts, water
tank…). Navigating equipment is checked and found in working condition.
Ground tackle and mooring arrangements
Ground tackle consist of electrical anchor winch “LIGHTHOUSE”, main anchor and
galvanized chain. Winch is tested and found in working condition. Boat is equipped with
two spare anchors. Chain locker is found in good order. Anchor, anchor chain and anchor
housing are found in good order. Emergency steering is tested and found in working
condition.
Page 9
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Adress: Doverska 32 a, 21000Split, Croatia
4. Conclusion Boat is fully equipped in accordance with requirements on the Regulations that are
applicable to Pleasure Craft. Did not find any deficiency which could affect her
seaworthiness. Equipment with expiring service or valid date should be renewed/serviced.
Deficiencies find are minor and should be rectified before next season. It is
recommended renewal of osmosis treatment next docking. In general I can say that boat
is old but well maintained.
Survey has been held with the boat afloat and on cradle, without making removals or
opening up of machinery except as stated. This examination therefore is subject to any
conditions which would have been revealed if such procedures had or will be
accomplished.
Page 10
______________________________________________________________________________________ Tel +385 21 459 762, Fax +385 21 459 763, Mob +385 98 601691, Mail [email protected]
Adress: Doverska 32 a, 21000Split, Croatia
5. Attachments
1. Bacalja Sinisa Appointment from Government of Croatia for Sworn Court Surveyor
(Naval architecture and Marine engineering)
2. Pictures
mag. ing. Ante Babarović Ing. Bacalja Siniša
Marine Surveyor Sworn Court Surveyor
Report date and place: Split, 08.08.2014. Page 11
REPUBLIKA HRVATSKATRGOVAČKI SUD U SPLITUURED PREDSJEDNIKA SUDA
Split ,29.,siječnja'H2013 •.godine
Predsjednik Trgovačkog suda u Splitu, u postupku imenovanja stalnih sudskihvještaka, temeljem odredbe članka 140.stavak 3. Zakona o sudovima (Narodnenovine" broj:122110-pročišćeni tekst, 27/11 i 130/11) i članka 8. stavak 1. i 2.Pravilnika o stalnim sudskim vještacima ("Narodne novine" broj: 88/08., 8/09.i126/11), dana 29. siječnja 2013. godine
riješio je
I SINIŠA BACALJA, ing. strojarstva iz Splita, Doverska 32a, om:71809148552 ponovno se imenuje stalnim sudskim vještakom za brodostrojarstvoi brodogradnju.
II Stalni sudski vještak se imenuje za vrijeme od 4 (četiri) godine, a po protekutoga roka može biti ponovno imenovan.
Obrazloženje
Siniša Bacalja ing.strojarstva iz Splita, Doverska 32a, je podnio zahtjev zaponovnim imenovanjem za stalnog sudskog vještaka Trgovačkog suda u Splitu zabrodostrojarstvo i brodogradnju, gdje je već ranije imenovan sudskim vještakom uovom sudu rješenjem broj 4 Su-651/08 od 9. veljače 2009. godine. Svom zahtjevu jepriložio uvjerenje da se protiv istog ne vodi istraga i da nije podignuta optužnica kojaje stala na pravnu snagu, policu osiguranja i svjedodžbu o zdravstvenoj sposobnostiradnika.
Nakon pribavljenih podataka propisanih odredbom članka 2. Pravilnika ostalnim sudskim vještacima, te izvoda iz kaznene evidencije Klasa:703-04/13-01/5688, Urbr: 514-05-01-01-13-02-1807465 od 22.01.2013. godine, utvrđeno je daimenovani ispunjava postavljene uvjete, pa je slijedom iznijetog trebalo odlučiti kao uizreci rješenja.
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Forward part Aft part
Side view
Side view
Aft platform
Bathing ladders
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Deck aft part
Deck forward part
Access to deck
Gangway
Davits
Solar panel
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Grill
LPG bottles are not safely stored
Storage
Spare anchor
Ropes
Emergency steering
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Deck windows are found in good order
Side windows are found in good order
Dinghy
Honda engine
Spare Mercury engine
Railings are found in good order
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Cleats are found strong
Stress cracks on deck
Forward part
Electric winch
Main anchor
Spare anchor
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Access to forward cabin Chain
Chain locker
Furling Genoa
Genoa sail Genoa sail is found in acceptable condition
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Masts
Equipment
Radar and wind generator
Mast upper part
Forward mast
Mast upper part
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Forward mast base
Aft mast base
Winches on mast
Winch on mast
Ropes
Ropes
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Lazy bag
Lazy bag
Main sail is found in poor condition
Fore sail is found in acceptable condition
All side stays are found in good order
All side stays are found in good order
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Wooden parts need regular maintenance
Cockpit
Winch
Winch is found operational
Skipper post
Compass
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Steering wheel Engine commands
Depth sounder
Detail
Radar is operational
Windex
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Autopilot
VHF
Stainless steel construction
Spray hood
Bimini
Canvas are found in good order
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Entrance to lower deck
Entrance can be locked
Wooden stairs
Galley
Skipper post
SSB
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Signal receiver
VHF with AIS
GPS
Autopilot
Multi instrument
Barometer
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Main switch board
Switches
Indicators
Indicators
Switches
Hand held VHF
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Obsolete wires Windows are found in good order and leak free
Sofa and table
Small sofa
Ventilation
Bilges
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Water tank
Fuel tank
Bilges
Electric installations
Bilges
Double stainless steel clip
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Forward cabin
Bilge
Forward sanitary facilities
Window
Alleyway
Interior is found in good order
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Batteries
Batteries switch
Aft cabin
Bilges
Autopilot
Hydraulic rudder system
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Aft sanitary facilities
Access to engine room
Engine
Electric installations
Inverter
Fuel filter
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Engine compartment Engine bilges
Generator
Water heater
Detail
Engine hours
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Bilges
Sea valves are found in good order
Fuel
Propeller shaft
Manual bilge pump
Obsolete wires
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Rescue ring
Man overboard
Lifesling
Life raft
Satellite tracker
All extinguishers are out of service date
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Epirb
Binocular
Safety equipment
Safety equipment
Safety equipment
Safety equipment
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 06-08-2014>
Safety equipment
Storm sail
Pyrotechnics
First aid kit
Safety equipment
Safety equipment
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 08-08-2014>
Aft part Forward part
Side view
Side view
Vertical sides are found in good order
Vertical sides are found in good order
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 08-08-2014>
Underwater part is found without damages
New Anti-fouling protection should be applied
Keel
Keel
Hull fittings
Hull fittings
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 08-08-2014>
Underwater part
Rudder
Rudder bearing is found in good order
Propeller is damage free
Propeller shaft
New Zing anodes
MORGAN KETCH 492 S/V “PLANKTON” <Marina Kaštela, 08-08-2014>
Old osmosis craters
Barcol hardness test is found in good order
Alarm on thick layer of paint
On Gelcoat spot is found good reading
On some places are found very good readings
Hull number