Checklist DA42 GFC700 LEP 18 - Diamond Aircraft Industries

Checklist for Diamond DA42 – GFC700 Edition #: 18 Edition date: 15.12.2017 Please observe: The file you are receiving hereby combines all three sections of the checklist: Normal Checklist, Emergency Checklist and Abnormal Checklist. All pages of a new edition will have the same new “edition #” and “edition date”, even if only one page was amended and all other pages still have the same, unchanged content. Therefore the “List of Effective Pages” (LEP) is provided. It is here where you can see whether a particular page was amended. Pages which have been amended by a new edition will be marked yellow. For all other pages you will see which original “edition #” (and of course any higher “edition #”) is still valid. Note:

The system of assigning “Edition #” is as follows: • if the revision affects all types, a new edition # (without a decimal figure) will be

assigned to all of the checklists • if the revision does not affect all types, the affected checklists will get subsequent

“decimal figures” until a major revision affecting all checklists is issued. Have a lot of nice flights and happy landings! Peter Schmidleitner Comments explaining Edition # 18 are on page 2 of this document Checklist DA42 GFC700 - LEP

Following Page Edition Date

(or any higher) is valid

Section : Normal Checklist 1 14 01.12.20062 16.2 01.03.20153 14.1 01.07.20084 16.2 01.03.20155 17.2 15.04.20176 16 01.12.20127 17.1 15.03.20178 16.2 01.03.20159 17.1 15.03.201710 15.2 15.02.2012

Section: Emergency Checklist

1 18 15.12.20172 18 15.12.20173 18 15.12.20174 18 15.12.20175 18 15.12.20176 18 15.12.20177 18 15.12.20178 18 15.12.20179 18 15.12.201710 18 15.12.201711 18 15.12.201712 18 15.12.201713 18 15.12.201714 18 15.12.2017

Section: Abnormal Checklist 15 18 15.12.201716 18 15.12.201717 18 15.12.201718 18 15.12.201719 18 15.12.201720 18 15.12.2017

Comments explaining Edition # 17.2 Normal Procedures: Page 5: Engine Start Procedure: “Prop Area….CLEAR” placed on top Comments explaining Edition # 18 Normal Procedures: No change Emergency Procedures: Pages rearranged and renumbered Major changes: Page 5: L/R STARTER Pages 6/7: Engine Fire Abnormal Procedures: Pages renumbered

DA42 Twin Star GFC700

15.12.2017 Diamond Flight Training Page 1

NORMAL CHECKLIST

Edition # 18 GFC700 Does not replace the Airplane Flight Manual

Diamond DA42 Twin Star GFC700

This checklist is compiled according the guidelines of GAMA Specification No.1, SECTION 3, para 3.5, SECTION 3A, para 3A.5 and SECTION 4, para 4.5. The “Amplified Normal Procedures”, „Amplified Emergency Procedures“ and „Amplified Abnormal Procedures“ according GAMA Specification No. 1 are in the DA42 Airplane Flight Manual Chapters 4A, 3 and 4B. This checklist is a Recommended Operator Checklist and for reference only. It is not a substitute for and does not supersede the current approved Airplane Flight Manual or any of its supplements or parts thereof, or any training or procedures required by any regulatory or advisory bodies. This checklist may not contain all procedures shown in the Airplane Flight Manual. For a comprehensive listing of all procedures consult the Airplane Flight Manual. Use of the checklist is at the user's sole risk and discretion. Any possible liability of Diamond Aircraft for any damages, injury or death resulting from its use is excluded. All such terms and conditions shall be deemed to be explicitly accepted in full by using the checklist. If you do not understand, or if you disagree with, any of the above terms and conditions and in any jurisdiction that does not give effect to all provisions of these terms and conditions any use of the checklist is not permitted. Use of the electronic checklist (if available): Before using the electronic checklist on the G1000 the following sections have to be completed using this paper checklist: • Preflight interior + exterior • Preflight exterior • Check before engine start items 1 to 22 (may be completed by heart). This checklist also serves as a back up for the electronic checklist in case the G1000 MFD is not available.

DA42 Twin Star GFC700 PREFLIGHT PROCEDURES

15.12.2017 Diamond Flight Training Page 2 Edition # 18 GFC700 Does not replace the Airplane Flight Manual

22 Check external lights

* if optional ice protection is

installed ** if optional AUX tanks are

installed *** with option ‘increased ZFM’ and

actual ZFM > 1650 kg

PREFLIGHT INTERIOR + EXTERIOR. 1 Check airplane documents 2 Remove pitot cover 3 Check interior for foreign

objects 4 Check circuit breakers 5 Start key PULLED OUT 6 Gear selector CHECKED DOWN 7 Electric Master ON

Check battery voltage 8 Gear 3 greens CHECKED 9 Check fuel quantity + temp

10 ** Fuel transfer ON – if L/R AUX FUEL E caution ON: AUX tank(s) empty Fuel transfer OFF

11 External lights ON 12 Parking brake SET 13 Pitot heat ON 14 * Check de-ice fluid quantity 15 * Select de-ice pump 1 16 * De-ice HIGH/MAX 17 * Check DEIC PRES LO+HI out 18 * Select de-ice pump 2 19 * Check DEIC PRES LO+HI out 20 * Ice lights ON 21 * Check de-ice function

23 Check stall warning 24 Check pitot tube heat 25 Pitot heat OFF 26 External lights OFF 27 * De-ice, ice lights OFF 28 Electric Master OFF

PREFLIGHT EXTERIOR Attention!

For refuelling with JET A1 no additives (e.g. „Aerojet“) are permitted.

Canopy left side

Left main gear Strut (min 4cm bare piston) &

downlock Tire condition, pressure (4,5 bar),

position mark Brake, hydraulic line Gear door & linkage *** structural temp.indicator:

no “red 55”

Left engine nacelle Drain cascolator 3 air inlets / 2 air outlets Spinner, propeller Gearbox oil level Engine oil level Cowling Nacelle underside Venting pipe Exhaust ** Check AUX tank full ?

Left wing Wing leading edge, top- and

bottom surface Tank drain Stall warning Tank air vent Fuel filler cap Pitot probe (cover removed) Wing tip, position light Static dischargers Aileron (freedom of movement,

hinges, control linkage, security)

Wing flap Fuel cooler air in- & outlet ** AUX tank vent ** Drain AUX tank

Left fuselage Step Rear cabin door Fuselage left side Static source Antennas

DA42 Twin Star GFC700 PREFLIGHT PROCEDURES


Tail Elevator & rudder (freedom of

movement, hinges) Elevator & rudder trim - tabs Tail skid & lower fin Static dischargers

Right fuselage Fuselage right side Static source Rear window Step

Right wing Fuel cooler air in- & outlet ** AUX tank vent ** Drain AUX tank Wing flap Aileron (freedom of movement,

hinges, control linkage, security)

Static dischargers Wing tip, position light Wing leading edge, top- and

bottom surface Fuel filler cap Tank air vent Tank drain Canopy right side

Right engine nacelle ** Check AUX tank full ? 3 air inlets / 2 air outlets Spinner, propeller Gearbox oil level Engine oil level Cowling Nacelle underside Venting pipe Exhaust Drain cascolator Ventilation air inlet

Right main gear Strut (min 4cm bare piston) &

downlock Tire condition, pressure (4,5 bar),

position mark Brake, hydraulic line Gear door & linkage

Nose section * De-ice fluid tank L + R front baggage door locked OAT sensor EPU connection Landing / Taxi light

Nose gear Strut (min 15cm bare piston) &

lock Tire condition, pressure (6 bar),

position mark Gear door & linkage Chocks removed Tow bar removed

DA42 Twin Star GFC700 NORMAL PROCEDURES


CHECK BEFORE ENGINE START 1 Preflight check ............................COMPLETED 1 2 Baggage and tow bar ...................... SECURED 2 3 **AUX PUMPS (2)................................... OFF 3 4 Fuel selectors (2)........ ON, safety guard closed 4 5 Power levers (2) .................................... IDLE 5 6 Parking brake......................................... SET 6 7 Alternate Air .................................... CLOSED 7 8 Manual gear extension handle ............ PUSHED 8 9 Gear selector ..................................... DOWN 9

10 Avionic master ....................................... OFF 10 11 Electric master ....................................... OFF 11 12 Engine masters (2) ................................. OFF 12 13 Pitot heat .............................................. OFF 13 14 Alternate static................................. CLOSED 14 15 Alternators (2) ........................................ ON 15 16 ECU swap (2) .......................................AUTO 16 17 All light switches..................................... OFF 17 18 Emergency switch.................... OFF/GUARDED 18 19 ELT...................................................ARMED 19 20 Circuit breakers .......................... CHECKED IN 20 21 Flap selector ............................................UP 21

If starting with external power:

a Prop area ....................... CHECK CLEAR a b External power...................... CONNECT b

22 Electric master ........................................ ON 22 23 Rudder pedals ...............................ADJUSTED 23 24 Flight controls ................................ CHECKED 24 25 Trims ............................................ CHECKED 25 26 Gear warning + lights, fire detector..........TEST 26 27 * De-ice ANNUN TEST .............................. ON 27 28 * DEICE LVL LO caution. CHECKED ON if applic. 28 29 * Windshield de-icing .....PUMP 1 + 2 CHECKED 29

Checklist continued next page



CHECK BEFORE ENGINE START continued

30 Flaps.....................................................LDG 30 31 Variable elevator backstop ................... CHECK 31

Control stick ............................... AFT and HOLD Power levers ............................................. MAX Check backstop limit decreasing Power levers .............................................IDLE Check backstop limit increasing

32 Flaps.......................................................UP 32 33 Passengers ............................... INSTRUCTED 33 34 Seat belts .....................................FASTENED 34 35 Rear door .................... CLOSED and LATCHED 35 36 Front Canopy ................................POS 1 or 2 36 37 G1000.................POWERED, ACKNOWLEDGED 37 38 MFD............................................ EIS – FUEL 38 39 Fuel Quantity .....CHECKED, RESET/SET if requ. 39 40 Fuel temperature ............................ CHECKED 40 41 Total time in service............................NOTED 41 42 MFD........................................EIS – SYSTEM 42 43 * DEIC PRESS LO caution ........... CHECKED ON 43 44 * De-ice ANNUN TEST ............................. OFF 44 45 Start key ...................................... INSERTED 45 46 Power levers (2) .................................... IDLE 46 47 ACL (strobe) ........................................... ON 47

End of Checklist

ENGINE START PROCEDURE Normal sequence: first start LH engine Propeller area ........................................ CLEAR Engine Master .............................................ON Annunciations / Eng.Instr. ...................CHECKED Glow indication ..........................................OFF Start key....START, do not release below 500 RPM Oil pressure ............... OUTSIDE RED within 3 sec Voltage, Electrical load ......... CHECK INDICATION Annunciations / Eng.Instr. .......................CHECK

If external power was used:

External power.................DISCONNECT Start RH engine, procedure as above



CHECK AFTER ENGINE START 1 Oil pressure ................................... CHECKED 1 2 RPM 900 +/- 20.............................. CHECKED 2 3 Warm up time .................................... START 3

Warm up: Idle ................................................. 2 minutes 1400RPM ............. until Oil > 50°C and Coolant > 60°C

4 Fuel selectors (2)............................... X-FEED 4 5 Pitot heat ....ON, annunciation + Amps checked 5 6 Pitot heat .............................................. OFF 6 7 Avionics master ....................................... ON 7

FMS SETUP I nitialize profile (AUX 4, MAP) F light plan R adios (COM, NAV, ADF, DME, CDI, BRG 1/2) P erformance (speed bugs; Flight ID if applicable)

8 FMS setup ..................................COMPLETED 8 AUTOPILOT TEST

DISCONN press, check electric trim not working AP ON, check annunciations and FD DISCONN press, check AP off GA button press, check FD commands climb, FD OFF

9 Autopilot test ..............................COMPLETED 9 10 Flood light .............. CHECKED, ON as required 10 11 Position lights..........................ON as required 11 12 Fuel Selectors (2) .................................... ON 12 13 Altimeters (2) ........................................ SET 13 14 Standby horizon ............................. CHECKED 14 15 Transponder ..............CODE / MODE CHECKED 15 16 Parking brake................................ RELEASED 16

End of Checklist

DURING TAXI Check brakes Check nose wheel steering Check flight instruments



BEFORE TAKE OFF CHECK 1 Parking brake......................................... SET 1 2 Seat belts .....................................FASTENED 2 3 Rear door ....................... CLOSED + LATCHED 3 4 Front canopy................... CLOSED + LATCHED 4 5 Front baggage doors ...........CHECKED CLOSED 5 6 Door warning light .................................. OFF 6 7 Engine instruments ......................... CHECKED 7 8 Fuel temperature (Diesel min. +5°)... CHECKED 8 9 Circuit breakers .............................. CHECKED 9

10 Electric elevator trim..........CHECKED, T/O SET 10 11 Fuel selectors (2)....................... CHECKED ON 11 12 Rudder trim ............................. AS REQUIRED 12 13 Flaps........................................ CHECKED UP 13 14 Flight controls ................................ CHECKED 14 15 Power levers (2) .................................... IDLE 15 16 ECU test (2)................................... PERFORM 16

ECU TEST ECU test button........................... press and hold “L/R ECU A/B fail”........ON / RPM increasing / OFF “L/R ECU B fail”...............ON / prop cycling / OFF “L/R ECU A fail”...............ON / prop cycling / OFF RPM......................................... decrease to idle ECU test button..................................... release

17 ECU swap (2) .........ECU B, ENGINES CHECKED 17 18 ECU swap (2) .......................................AUTO 18 19 Pitot heat ................................ AS REQUIRED 19 20 * Ice protection ........................ AS REQUIRED 20 21 Transponder ..............CODE / MODE CHECKED 21 22 MFD.......................................EIS – DEFAULT 22 23 Parking brake................................ RELEASED 23

End of Checklist LINE UP PROCEDURE

Landing light...............................................ON Approach sector ..................................... CLEAR Runway..........................................IDENTIFIED Power lever max (100% / 10 sec) ...........................

CHECK LOAD / RPM / FUEL FLOW / OP



AFTER TAKE-OFF PROCEDURE Brakes ...................................................APPLY Gear...........................................................UP Landing light..............................................OFF

CLIMB TO CRUISE CHECK 1 Gear ........................................ CHECKED UP 1 2 Flaps........................................ CHECKED UP 2 3 Landing light ............................CHECKED OFF 3

End of Checklist

PERIODICALLY DURING CRUISE Fuel Radio Engine Direction Altitude

Maximum fuel unbalance: 5 USG

DESCENT / APPROACH CHECK 1 Landing data ................................. RECEIVED 1 2 Altimeters (2) ........................................ SET 2 3 COM / NAV / FMS ................................... SET 3 4 Seatbelts ......................................FASTENED 4 5 Fuel selectors (2)....................... CHECKED ON 5 6 Parking brake..................CHECKED RELEASED 6 7 Rudder trim ............................. AS REQUIRED 7 8 Gear warning + lights.............................TEST 8

End of Checklist

BEFORE LANDING PROCEDURE Downwind, latest base leg: Flaps ........................................................ APP Gear...........................DOWN, CHECK 3 GREENS Landing light...............................................ON On final when landing assured:

FINAL CHECK 1 Flaps.....................................................LDG 1 2 Gear .............................. 3 GREENS CHECKED 2 3 Rudder trim ....................................NEUTRAL 3



GO AROUND PROCEDURE Power ...................................................... MAX Flaps ........................................................ APP Positive rate of climb: Gear...........................................................UP Continue with take-off profile At safe altitude: Flaps ..........................................................UP Landing light..............................................OFF

AFTER LANDING CHECK When clear of runway

1 Flaps.......................................................UP 1 2 Pitot heat .............................................. OFF 2 3 Alternate air..................................... CLOSED 3 4 * De-ice systems .................................... OFF 4 5 Landing/Taxi light ..................... AS REQUIRED 5

End of Checklist

PARKING CHECK 1 Parking brake......................................... SET 1 2 Power levers (2) ..................... IDLE for 2 min. 2 3 ELT................................CHECK not activated 3 4 Engine / System page ..................... CHECKED 4 5 Engine / Fuel page..... TTL TIME IN SVC NOTED 5 6 Avionic master ....................................... OFF 6 7 Electrical consumers except ACL (strobe) ... OFF 7 8 Engine Masters (2).................................. OFF 8 9 ACL (strobe) .......................................... OFF 9

10 Electric Master........................................ OFF 10 11 Interior light ............................CHECKED OFF 11 12 Start key .......................................REMOVED 12

End of Checklist SECURING THE AIRCRAFT

Release parking brake, use chocks. Cover the pitot probe. Attach tie down ropes to mooring points.

DA42 Twin Star GFC700 IMPORTANT DATA AND LIMITATIONS


OPERATING SPEEDS KIAS for MTOM 1785

1400 kg 1785 kg Stalling speed (VS0) Flaps LDG 54 62 Stalling speed (VS) Flaps APP 59 64 Stalling speed (VS) clean 63 69

In Ice: + 4 Kt Best gliding angle (Flaps UP) 85 Best angle of climb (VX) 82 Best rate of climb (VY) 82 Best rate of climb 1-eng. (VYSE) 85 Min. control speed (VMCA) 71 Min. control speed for TRG(VSSE) 85 Min. control speed (VMCA) in ice 75 Operating speed in ice 118 - 156 Cruising climb speed 88 Rotation speed 76 Max. flap speed (VFE) Flaps APP 133 Max. flap speed (VFE) Flaps LDG 113 Max. LG extension (VLOE) 188 Max. LG extended (VLE) 188 Max. LG retraction (VLOR) 152 1700 kg 1785 kg Approach VREF Flaps UP 87 88 Approach VREF Flaps APP 83 83 Approach VREF Flaps LDG 79 82 Min. Go-around speed Flaps UP 85 85 Max. cruising speed (VNO) 151 Never exceed speed (VNE) 188

up to

1542 kgabove -1542 kg

Manoeuvring speed (VA) 117 123

MASS

Increased LM ZFM LM + ZFMMax. TKOF mass 1785 kg Max. ZF mass 1650 kg 1674 kg 1730 kgMax. LDG mass 1700 kg 1785 kg 1785 kgEmpty mass 1295 kg

Max. baggage in NOSE 30 kg Max. baggage in COCKPIT 45 kgMax. baggage in rear EXTENSION 18 kgMax. total of COCKPIT + EXTENSION 45 kg

DA42 Twin Star GFC700


EMERGENCY + ABNORMAL CHECKLIST

2 engines out landing ............................................page 2 G1000 Warnings ...................................................page 3 Engine

Engine failure during take-off.....................page 7 Engine failure, engine shutdown in flight ....page 7 Engine troubleshooting .............................page 8 Engine restart..........................................page 9 Oscillating RPM ...................................... page 10 RPM overspeed ...................................... page 10

Landing Gear Landing with defective main gear tire........ page 10 Landing with defective brakes .................. page 10 Landing gear unsafe warning ................... page 11 Manual extension of landing gear ............. page 11 Landing gear up landing.......................... page 11

Smoke and fire Engine fire on ground or during take-off ......page 6 Engine fire in flight ...................................page 6 Electrical fire on ground .......................... page 12 Electrical fire in flight .............................. page 12

If Oxygen System is installed

Cabin smoke, cabin fire, above 10.000 ft ... page 13 Oxygen pressure loss above 10.000 ft....... page 13

Other Emergencies Emergency descent ................................ page 13 Unintentional flight into icing, Inadvertent icing encounter & excessive ice accumulation .... page 14 Ice protection failure .............................. page 14 Suspicion of carbon monoxide.................. page 14

Electrical System Complete electrical failure ....................... page 12

For conditions to use this Emergency + Abnormal Checklist

see page 1 of the Normal Checklist.

All such conditions are fully applicable also for this checklist.

DA42 Twin Star GFC700 EMERGENCY PROCEDURES


ENGINES OUT LANDING

1 Mayday call ....................................CONSIDER 1

2 Engine masters (2) ................................... OFF 2

3 Alternators (2) ......................................... OFF 3

4 Fuel selectors (2) ..................................... OFF 4

5 Avionic master ......................................... OFF 5

6 Safety harnesses............. FASTENED and TIGHT 6

When sure of making landing area:

7 Flaps .......................... APP or LDG, as required 7

8 Approach speed ...... min (APP)82/(LDG)78 KIAS 8

9 Power levers (2)...................................... IDLE 9

Gear UP landing

After touchdown:

10 Electric master......................................... OFF 10

Gear DOWN landing

11 Gear..................... DOWN, 3 GREENS CHECKED 10

12 Electric master......................................... OFF 11


10

11



G1000 WARNINGS L/R ALTN AMPS Pg. 3 High Current (red range) L/R OIL PRES Pg. 3 Oil pressure low (red range) L/R OIL TEMP Pg. 3 Oil temperature high (red range) L/R GBOX TEMP Pg. 4 Gearbox temperature high (red range) L/R ENG TEMP Pg. 4 Coolant temperature high (red range) L/R FUEL TEMP Pg. 4 Fuel temperature high (red range) L/R FUEL PRES Pg. 5 Fuel pressure low L/R STARTER Pg. 5 Starter not disengaging DOOR OPEN Pg. 5 Unlocked doors L/R ENG FIRE Pg. 6 Engine fire

on ground, during take-off, in flight

For other parameters “out of green range” see Abnormal Checklist Abnormal Checklist starts at page 15

L/R ALTN AMPS HIGH CURRENT

Check circuit breakers Reduce electrical load and land at nearest suitable airfield


L/R OIL PRES OIL PRESSURE LOW

Reduce power on affected engine Be prepared for loss of oil and an engine failure;

land at nearest suitable airfield

L/R OIL TEMP OIL TEMPERATURE HIGH

Check oil pressure If oil pressure too low (outside green range):

⇒ Reduce power on affected engine ⇒ Expect loss of engine oil ⇒ Be prepared for an engine failure

If oil pressure in green range ⇒ Reduce power on affected engine ⇒ Increase airspeed

If oil temperature not returning to green range: ⇒ Be prepared for an engine failure;

land at nearest suitable airfield




L/R GBOX TEMP GEARBOX TEMPERATURE HIGH

Reduce power on affected engine Increase airspeed

If gearbox temperature still in red range: ⇒ Land at nearest suitable airfield ⇒ Be prepared for an engine failure

L/R ENG TEMP COOLANT TEMPERATURE HIGH

Check G1000 for LOW COOL LVL caution light If LOW COOL LVL caution light OFF

During climb: ⇒ Reduce power on affected engine by 10%

or more as required ⇒ Increase airspeed by 10 KIAS or more as required

If coolant temp. not returning to green range within 60”:

⇒ reduce power on affected engine as much as possible and increase airspeed

During cruise: ⇒ Reduce power on affected engine ⇒ Increase airspeed

If coolant temp. not returning to green range: ⇒ Be prepared for an engine failure;

land at nearest suitable airfield If LOW COOL LVL caution light ON

⇒ Reduce power on affected engine ⇒ Expect loss of coolant fluid ⇒ Be prepared for an engine failure

L/R FUEL TEMP FUEL TEMPERATURE HIGH

Reduce power on affected engine Increase airspeed Transfer fuel from AUX to MAIN tank if applicable

If not returning to green range: ⇒ Land at nearest suitable airfield




L/R STARTER STARTER NOT DISENGAGING

On ground: ⇒ Affected power lever IDLE ⇒ Affected engine master OFF ⇒ Electric master OFF

In flight: ⇒ Pull LDG LT/START CB (RH Main Bus; push again when

LDG light needed) ⇒ Watch engine cowling and instruments ⇒ Land at nearest suitable airfield

DOOR OPEN UNLOCKED DOORS

Reduce airspeed immediately Check canopy visually

If open: ⇒ airspeed below 140 KIAS, land at nearest suitable airfield

Check rear door visually If open:

⇒ airspeed below 140 KIAS, land at nearest suitable airfield ⇒ do not try to lock door in flight

Check front baggage doors visually If one or both open:

⇒ reduce airspeed to keep door(s) in stable position, land at nearest suitable airfield



G1000 WARNING

L/R ENG FIRE OR ENGINE FIRE OBSERVED On ground:

1 Engine masters (2) ................................... OFF 1 2 Fuel selectors (2) ..................................... OFF 2 3 Mayday call ....................................CONSIDER 3 4 Electric master......................................... OFF 4

When engine and aircraft stopped: 5 Canopy ................................................. OPEN 5

Evacuate During Take-off

1 Cabin heat & defrost ................................. OFF 1 2 Emergency windows (2) .......................... OPEN 2 3 Proceed according

ENGINE FAILURE DURING TAKE-OFF page 7… 3 G1000 WARNING

L/R ENG FIRE

In flight: ⇒ Evaluate the situation

If Engine Fire observed: ⇒ Proceed according

ENGINE FIRE IN FLIGHT page 7




ENGINE FAILURE DURING TAKE-OFF REJECTED TAKE-OFF OR EMERGENCY RE-LANDING

1 Power ..................................................... OFF 1 2 Brakes ................................................. APPLY 2 3 ATC ...................................................INFORM 3

If necessary: 4 Engine Masters (2) ................................... OFF 4 5 Fuel selectors (2) ..................................... OFF 5 6 Electric Master ......................................... OFF 6

ENGINE FAILURE DURING FLIGHT AND ENGINE SHUTDOWN

If airspeed below Vmca: Perform Vmc recovery procedure

Airspeed above Vmca: 1 Power ............................. INCREASE up to MAX 1 2 Airspeed................................... min BLUE LINE 2 3 Landing gear ............................................. UP 3 4 Flaps ........................................................ UP 4 5 Power lever (affected engine)..REDUCE TO VERIFY 5 6 Engine Master (affected engine) ................. OFF 6

Above safe altitude 7 Power (life engine) ...... up to MAX CONTINUOUS 7 8 Alternator (dead engine) ........................... OFF 8 9 Fuel selector (dead engine)........................ OFF 9

ENGINE FIRE IN FLIGHT 1 Cabin heat & defrost ................................. OFF 1 2 Canopy .......................... UNLATCH if necessary 2

Max airspeed 120 KIAS 3 Shut down the engine according

ENGINE SHUT DOWN-procedure



ENGINE TROUBLESHOOTING 1 Power lever (good engine). INCREASE up to MAX 1 2 Power lever (affected engine).................... IDLE 2

If in icing conditions:

3 Alternate air .......................................... OPEN 3

4 Fuel quantity ....................................... CHECK 4 5 AUX transfer (affected engine) ..........CONSIDER 5 6 Fuel selector (affected engine) ..... ON or X-FEED 6 7 ECU swap (affected engine) .................... ECU B 7

If successful: land ASAP

If unsuccessful: 8 ECU swap (affected engine) ..................... AUTO 8 9 Circuit breakers........................ CHECK / RESET 9

If successful: land ASAP

If unsuccessful: continue with ENGINE FAILURE IN FLIGHT checklist




Wording and figures in italic print are for the TAE 125-01 engine.

ENGINE RESTART Engine restart is possible up to 8000 (6000) ft pressure altitude 1 Airspeed

For starter assisted restart: ........ below 90 KIAS 1 For windmilling restart: .............125 – 145 KIAS 1

2 Power (affected engine) .......................... IDLE 2 3 Fuel selector (affected engine) ................... ON 3 4 Alternate air ............................. AS REQUIRED 4 5 Alternator (affected engine) ....................... ON 5 6 Engine Master (affected engine) ................. ON 6

For starter assisted restart: 7 Starter.............................................ENGAGE 7

until 500 RPM or prop windmills

If engine started: 8 Power (affected engine) .................MODERATE 8 9 Engine instruments.......... check GREEN RANGE 9

10 Circuit breakers............................... CHECKED 10

If engine did not start (re-feathering procedure): One attempt only, expect altitude loss of up to 800 (500) ft

8 Airspeed........................................... 85 KIAS 8 9 Power lever (affected engine)................... MAX 9

10 Engine Master (affected engine) .......CHECK ON 10 11 Airspeed.......... INCREASE to achieve 1800 RPM 11 12 Engine Master (affected engine) ................ OFF 12 13 Airspeed........................... REDUCE to 85 KIAS 13 14 Propeller ...........................CHECK FEATHERED 14 15 Alternator (dead engine) .......................... OFF 15


16 Fuel selector (dead engine)....................... OFF 16



OSCILLATING RPM 17 Power lever ............................. change setting 1

If no success: 18 ECU swap............................................ ECU B 2

If no success: 19 ECU swap.............................................AUTO 3

Land at nearest suitable airfield

RPM OVERSPEED 20 Power setting.................................... REDUCE 1

If no success: 21 ECU swap............................................ ECU B 2

If no success: 22 ECU swap.............................................AUTO 3

Land at nearest suitable airfield Be prepared for ENGINE FAILURE IN FLIGHT

LANDING WITH DEFECTIVE MAIN GEAR TIRE 1 ATC ...............................................INFORMED 1

For landing: Land on RWY side with “good” tire Keep wing on “good” side low Support directional control with brake

LANDING WITH DEFECTIVE BRAKES After touchdown (if necessary):

23 Engine Masters (2) ................................... OFF 1 24 Fuel selectors (2) ..................................... OFF 2 25 Electric Master ......................................... OFF 3



LANDING GEAR UNSAFE WARNING If on for more than 20 seconds:

1 Airspeed....................................max 152 KIAS 1 In cold temperature:

2 Airspeed....................................max 110 KIAS 2 3 Gear selector .................................... RECYCLE 3

If landing gear extension unsuccessful: Continue with MANUAL EXTENSION

If landing gear retraction unsuccessful: Consider flight with landing gear down

MANUAL EXTENSION OF LANDING GEAR 1 Airspeed....................................max 152 KIAS 1 2 Gear indicator lights ................................TEST 2 3 Electric master................................ CHECK ON 3 4 Bus voltage ............................ CHECK NORMAL 4 5 Circuit breaker ..................................... CHECK 5 6 Gear selector ........................................DOWN 6 7 Manual extension handle .......................... PULL 7

If necessary 8 Airspeed....................................max 110 KIAS 8

Apply moderate yawing 9 Gear indicator lights .............. CHECK 3 GREENS 9

LANDING GEAR UP LANDING (Landing gear completely retracted)

1 Approach ..........................................NORMAL 1 If time/situation allows: just before touchdown:

2 Power lever ............................................ IDLE 2 3 Engine Masters (2) ................................... OFF 3 4 Fuel selectors (2) ..................................... OFF 4

Immediately after touchdown: 5 Electric Master ......................................... OFF 5




ELECTRICAL FIRE ON GROUND 1 Mayday call ....................................CONSIDER 1 2 Electric Master ......................................... OFF 2 3 Power levers (2)...................................... IDLE 3 4 Engine Masters (2) ................................... OFF 4 5 Fuel selectors (2) ..................................... OFF 5

When engine and aircraft stopped: 6 Canopy ................................................. OPEN 6

Evacuate

ELECTRICAL FIRE IN FLIGHT 1 Emergency switch ......................................ON 1 2 Mayday call ....................................CONSIDER 2 3 Avionic master ......................................... OFF 3 4 Electric master......................................... OFF 4 5 Cabin heat & defrost ................................. OFF 5 6 Emergency windows ............ OPEN as necessary 6 7 Canopy .......................... UNLATCH if necessary 7

Max airspeed 120 KIAS Land at nearest suitable airfield

COMPLETE ELECTRICAL FAILURE * Leave icing area

1 Circuit breakers............................CHECK all IN 1 If no success:

2 Emergency switch ......................................ON 2 3 Flood light, if necessary...............................ON 3 4 Power ..................................................... SET 4

according power lever position and/or engine noise 5 Flaps ...................................VERIFY POSITION 5

Land at nearest suitable airfield Landing gear may slowly extend

For landing apply “Manual extension of landing gear”


CABIN SMOKE ABOVE 10.000 FT 1 Oxygen .......................................... CHECK ON 1 2 Emergency descent ........................... INITIATE 2

When passing 10.000 ft 3 Oxygen ................................................... OFF 3


CABIN FIRE ABOVE 10.000 FT 1 Oxygen ...........................................PUSH OFF 1 2 Emergency descent ..........................INTITIATE 2


OXYGEN PRESSURE LOSS ABOVE 10.000 FT 1 Oxygen ...........................................PUSH OFF 1 2 Oxygen pressure ..............CHECKED, note down 2 3 Emergency descent ............................ INTIATE 3

When passing 10.000 FT: 4 Oxygen pressure ........................ CHECK AGAIN 4

If oxygen pressure constant:.....Continue flight If oxygen pressure dropped: ....Land at nearest

suitable airfield

EMERGENCY DESCENT 1 Flaps ........................................................ UP 1 2 Landing Gear ........................................DOWN 2 3 Power levers........................................... IDLE 3 4 Airspeed.................................... AS REQUIRED 4


If O

xy

ge

n S

ys

tem

is

in

sta

lle

d

If O

xy

ge

n S

ys

tem

is

in

sta

lle

d



UNINTENTIONAL FLIGHT INTO ICING Leave icing area, continue with item 1

* INADVERTENT ICING ENCOUNTER & EXCESSIVE ICE ACCUMULATION

1 Pitot heat ..................................................ON 1 2 Cabin heat & defrost ...................................ON 2 3 Power ....................... INCREASE PERIODICALLY 3 4 * De-ice systems................. USE as appropriate 4 5 Alternate air ..........................OPEN as required 5 6 Emergency windows ...............OPEN as required 6

When pitot heat fails: 7 Alternate static valve .............................. OPEN 7 8 Emergency windows ........................... CLOSED 8

* When de-ice system does not work properly: Continue with ICE PROTECTION FAILURE

* ICE PROTECTION FAILURE 1 Airspeed.......................min 118 KIAS until final 1 2 Flaps ........................................................ UP 2 3 Slip angle ........................................MINIMIZE 3 4 Approach with residual ice ................... 92 KIAS 4 5 Landing distance ......................................x1,4 5

SUSPICION OF CARBON MONOXIDE 1 Cabin heat & defrost ................................. OFF 1 2 Ventilation............................................. OPEN 2 3 Emergency windows ............................... OPEN 3 4 Airspeed....................................max 117 KIAS 4 5 Canopy ............................................UNLATCH 5

Push up and lock in cooling gap position

DA42 Twin Star GFC700 ABNORMAL PROCEDURES


G1000 CAUTION LIGHTS L/R ECU A FAIL Page 15 ECU A failed L/R ECU B FAIL Page 15 ECU B failed L/R VOLTS LOW Page 15 Bus voltage too low L/R ALTN FAIL Page 15 Alternator failed L+R ALTN FAIL Page 16 Both Alternators failed L/R COOL LVL Page 16 Engine coolant level low PITOT FAIL Page 16 Pitot heating system failed PITOT HT OFF Page 16 Pitot heating system OFF STALL HT FAIL Page 16 Stall warning heating failed STALL HT OFF Page 16 Stall warning heating OFF L/R FUEL LOW Page 16 Main tank fuel qty low L/R AUX FUEL E Page 16 L/R auxiliary fuel tank empty STICK LIMIT Page 17 Stick limiting system failed DEICE LVL LO Page 17 De-icing fluid level low DEIC PRES LO Page 17 De-icing pressure low DEIC PRES HI Page 17 De-icing pressure high

Engine instrument indications outside of green range

COOLANT temperature high/low .................. page 18 OIL temperature high/low........................... page 18 OIL pressure high/low................................ page 18 FUEL temperature high/low......................... page 18 VOLT low.................................................. page 19 RPM high.................................................. page 19

Other abnormal situations Hydraulic pump fail or continuous ops... page 19 AUX fuel transfer fail ............................. page 19


CAUTION ALERTS ON THE G1000

L/R ECU A OR B FAIL ON GROUND Discontinue operation, terminate flight preparation

L/R ECU A FAIL DURING FLIGHT Remark: in case of ECU A fail the system automatically switches to ECU B

Press ECU TEST button for more than 2 seconds If ECU A caution message re-appears or cannot be reset:

⇒ Land at nearest suitable airfield If ECU A caution message can be reset

⇒ Continue flight. Engine must be serviced after LDG

L/R ECU B FAIL DURING FLIGHT Press ECU TEST button for more than 2 seconds

If ECU B caution message re-appears or cannot be reset: ⇒ Land at nearest suitable airfield

If ECU B caution message can be reset ⇒ Continue flight. Engine must be serviced after LDG


L/R VOLTS LOW BUS VOLTAGE TOO LOW

Remark: possible reasons are - fault in the electrical power supply - Alternators OFF

Continue with “Engine instrument indications outside of green range” – VOLTS low, page 19

L/R ALTN FAIL ALTERNATOR FAILED

If in icing conditions: ⇒ Leave icing area as soon as practicable

Alternator on affected side OFF Monitor bus voltage Reduce electrical consumers If both alternators failed:

⇒ See Abnormal Checklist “Both Alternators failed”, page 16


L ALTN FAIL

R ALTN FAIL BOTH ALTERNATORS FAILED

Reduce all electrical equipment to a minimum: Avionic Master: OFF LH/RH Alternator: OFF Transponder: STBY Gear: DOWN

When down and locked: ⇒ Pull manual gear extension handle Stall/Pitot heat: OFF All lights:OFF ⇒ Expect battery power to last for 30 minutes ⇒ Expect engine stoppage after this time

⇒ Land ASAP


L/R COOL LVL ENGINE COOLANT LEVEL LOW

Monitor annunciations / engine instruments Check coolant temperature See “Engine instrument indications outside of green range” –

COOLANT TEMPERATURE

PITOT FAIL PITOT HT OFF

STALL HT FAIL STALL HT OFF

check pitot heat ON, if in icing conditions ⇒ expect failure of the

pitot-static-system ⇒ alternate static valve: OPEN

⇒ expect loss of aural stall warning

leave area with icing conditions (see Emergency Checklist page 13“Unintentional flight into icing”)

L/R FUEL LOW MAIN TANK FUEL QTY LOW

Check fuel quantity If LH & RH quantities show remarkable difference:

⇒ Expect loss of fuel on side with lower indicaton ⇒ Use x-feed: Fuel selector to x-feed on side

with LOW FUEL indication

L/R AUX FUEL E AUXILIARY FUEL TANK EMPTY

⇒ L/R auxiliary fuel pump OFF

+


STICK LIMIT VARIABLE ELEVATOR BACKSTOP SYSTEM FAILED

1 or 2 power levers set for MORE than 20% load: ⇒ Elevator variable backstop is INOP ⇒ Do not stall in any configuration!

2 power levers set for LESS than 20% load: ⇒ Elevator variable backstop always ACTIVE ⇒ Reduced elevator capacity ⇒ For approach min VREF 79/82 KIAS


DEICE LVL LO DE-ICING FLUIS LEVEL LOW

Maximum duration of ice protection in NORMAL mode: 45 min, in HIGH mode: 22 min

DEIC PRES LO DE-ICING PRESSURE LOW

Switch DE-ICE to HIGH If DEIC PRES LO light still ON

⇒ PUMP1 / PUMP2: select other pump ⇒ If necessary prime pump by activating

windshield pump If DEIC PRES LO light still ON

⇒ Activate ALTERNATE switch If DEIC PRES LO light still ON

⇒ Go to Emergency Checklist page 13 ICE PROTECTION FAILURE

If DEIC PRES LO light OFF ⇒ Continue flight

(de-icing fluid flow: 30 lt/hr) ⇒ Monitor ice protection system operation ⇒ Check de-icing fluid level periodically

DEIC PRES HI DE-ICING PRESSURE HIGH

Possible reduced system performance Filter cartridge to be replaced at next scheduled maintenance


ENGINE INSTRUMENT INDICATIONS OUTSIDE OF GREEN RANGE

COOLANT temperature high Refer to Emergency Checklist page 4, “L/R ENG TEMP”

COOLANT temperature low Remark: During low power descent from high altitude coolant temperature may decrease. Consider increasing power.

Check G1000 for LOW COOLANT LVL caution light If “LOW COOLANT LVL caution light” ON

⇒ Reduce power on affected engine ⇒ Expect loss of coolant fluid ⇒ Be prepared for an engine failure

OIL temperature high Refer to Emergency Checklist page 3, “L/R OIL TEMP”

OIL temperature low Increase power Reduce airspeed

OIL pressure high Check oil temperature and coolant temperature

If within green range ⇒ Oil pressure indication may be faulty; watch temperatures

If outside of green range ⇒ Reduce power on affected engine; ⇒ Be prepared for an engine faiure;


OIL pressure low Refer to Emergency Checklist page 3, “L/R OIL PRES”

FUEL temperature high Refer to Emergency Checklist page 4, “L/R FUEL TEMP”

FUEL temperature low (JET Fuel operation) Monitor fuel temperature

If fuel temperature decreases to red range (< 30°C): ⇒ Increase power on affected engine ⇒ Reduce airspeed

If not returning to yellow range: ⇒ Land at nearest suitable airfield

FUEL temperature low (Diesel Fuel operation) Increase power on affected engine Reduce airspeed

If not returning to green range:


⇒ Land at nearest suitable airfield


VOLTS low On ground:

⇒ Check alternators ON ⇒ Check circuit breakers

If LOW VOLTS CAUTION still indicated on the G1000: ⇒ Discontinue operation; terminate flight preparation

In flight: ⇒ Check alternators ON ⇒ Check circuit breakers ⇒ Switch off unnecessary electrical equipment

If LOW VOLTS CAUTION still indicated on the G1000: ⇒ Apply L/R ALTN FAIL caution procedure, page 15

RPM high Reduce power on affected engine Keep RPM in green range with appropriate power lever setting

If problem not solved: ⇒ Refer to Emergency Checklist page 9 “RPM overspeed” ⇒ Land at nearest suitable airfield

OTHER ABNORMAL SITUATIONS

Hydraulic pump: failure or continuous operation Check gear indication lights Prepare for manual landing gear extension

L/R Auxiliary fuel XFER FAIL Both x-fer pumps OFF Check fuel quantity Use X-feed to keep main tank fuel unbalance within 1 USG Switch remaining x-fer pump ON Use X-feed to keep main tank fuel unbalance within 1 USG Amend flight plan to allow for reduced amount of available fuel


FMS Intitialization – AUX 4 page Recommended and compulsory settings

TIME FORMAT UTC

NAV ANGLE AUTO

DIS. SPD NAUTICAL

ALT. VS FEET

TEMP CELSIUS

FUEL, FF GALLONS

POSITION HDDD°MM.MM’

AIRSPACE ALERTS As desired

ARRIVAL ALERT As desired

VOICE As Desired

MFD DATA BAR FIELDS 1 GS

2 DIS

3 ETE

4 TRK

GPS CDI

SELECTED AUTO

COM CHANNEL SPACING

25,0 KHZ or 8,33 KHZ

NEAREST APT

RWY SURFACE As desired

MIN LENGHT As desired Compulsory:

ARINC 424 Distance Coding:

A B C D E 1 2 3 4 5 F G H I J 6 7 8 9 10K L M N O 11 12 13 14 15P Q R S T 16 17 18 19 20U V W X Y 21 22 23 24 25

Intercept Procedures Typically two fighters approach from the stern -- you may only see one Fighter rocks wings to signal intercept Fighter responsible for safe separation

Your Actions Remain predictable – Altitude, heading, airspeed, don’t descend Acknowledge fighter with wing rock Talk to ATC Talk to fighter on 121.5

Post Intercept Comply with instructions Land where directed

Interceptor Signals Meaning

Fighter slow turn to desired heading FLY THIS WAY

Fighter abrupt turn across nose to desired heading and may dispense flares

WARNING: TURN NOW (DIRECTION OF FIGHTER)

Fighter circles airport, lowers landing gear, overflies runway in direction of landing LAND HERE

FLY THIS WAY

NIGHT INTERCEPT SIGNALS

Interceptor Signals

Meaning

Flash navigation lights

You have been intercepted

Turn on landing lights Land here

Your Signal Meaning

Flash navigation lights I will comply

Turn on landing light I will land

Flash landing light Airport inadequate

Flash all lights regular Can not comply

Flash all lights irregular Distress

DAY INTERCEPT SIGNALS

REASON GA AIRCRAFT ARE INTERCEPTED: Entering restricted airspace and not talking to ATC #1

NORAD / FAA / ICAO INTERCEPT PROCEDURES

Documents

Checklist DA42 GFC700 LEP 18 - Diamond Aircraft Industries