Embed Size (px)
Citation preview
BATTERY DISCHARGE TEST
1
BATTERY FORMS
10/10/2014
BATTERIES
PLANT
AUTOMATED
°FExample Plant
Example OwnerOWNER
%
ASSET ID
HUMIDITY
AMBIENT TEMP.
JOB #
DATE
PAGE
POSITION
SUBSTATION
10756, REVISED 1/10/2014COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
TESTED BY:TEST EQUIPMENT USED: Default Administrator
CATALOG NO.
OTHER
NAMEPLATE DATA
TEST PARAMETERS
-
OVERALL BATTERY VOLTAGE (V)
CAPACITY RATING (Ah)
0NUMBER OF CELLS
IEEE Std 450-2002
BATTERY
VOLTAGE (volts) CAPACITY (Ah)
Warning Limit
Stop Limit
LIMITS
00:00
00:00 0.00
0.0
0.0
TIME (HH:MM) CELL
CELL VOLTAGE (V)
0.00 5 5.00
SPEC. GRAVITY RANGE (g/cm3)
COMMISSION DATE
Constant I
TEST MODE NOMINAL CURRENT (A) TEST CURRENT (A) END CELL VOLTAGE (V) END BATTERY VOLTAGE (V) TIME (h)CORRECTED
TIME (h)
Internal
MANUFACTURER MODEL
Current Measurement Method:
Temperature Correction Method: 1.000Time Temperature correction using ambient temperature:
Initial Battery Status: Charged
0.00 0.00
0.00
Ah Change to Log:
Update Interval (Minutes):
TORKEL
0.25
0.050 10
Show Test Data:
Show Strap Table:Voltage Change to Log:
Preferred Tolerance:
Data Collection Mode:
0.05 Voltage Change to Log:
Number Of BVM Cells: 0 - 20 V
Minimum Cell Voltage:
Voltage Change
Cells Outside Limits:
BVM
Cell Numbering:
Show Data Tables:
Voltage Range:
Positive To Negative
HISTORICAL CAPACITY
CA
PA
CIT
Y (a
mp-h
ours
)
BATTERY DISCHARGE TEST
2PAGE
10756, REVISED 1/10/2014COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
VOLTAGE/CAPACITY VS. TIME
VOLTAGE:STOPVOLTAGE:WARNINGCAPACITY: STOPCAPACITY: WARNING____CAPACITY:MEASURED VOLTAGE:MEASURED_ _ _ ___ _______ _ _ _
Temp. Corrected Battery Capacity:Measured Battery Capacity (Ah): 0.0
Percent Capacity (%): 0.0 Actual Discharge Time:
@ 25 C Format Graph Axis
0:00:00
CELL #
Total
Avg.
Min.
Max
(g/cm3)
SPECIFIC GRAVITY
°F
Temp. RemarkVOLTAGE (volts)
VOLTAGE (volts)
Float (charging) Idle
Show Cell Data:
BATTERY DISCHARGE TEST
3PAGE
10756, REVISED 1/10/2014COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
Bar Graph Graphing cells from: 1 to:
Initial Voltage: _ _ ________ Stop Voltage:Warning Voltage:Voltage: ___
COMMENTS:
DEFICIENCIES:
BATTERY
VOLTAGE (volts) CAPACITY (Ah)
0.000Warning Limit
Stop Limit
LIMITS
0.000
00:00
00:00
0.000
0.000
0.0
0.0
BATTERY DISCHARGE TEST
4
BATTERY FORMS
10/10/2014
BATTERIES
PLANT
AUTOMATED
°FExample Plant
Example OwnerOWNER
%
ASSET ID
HUMIDITY
AMBIENT TEMP.
JOB #
DATE
PAGE
POSITION
SUBSTATION
Test Current (A)
0.00
TEST PARAMETERS
TEST MODE
Constant I
TIME (HH:MM)
Current Measurement Method:
CELL
10754, REVISED 3/19/2012COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
TESTED BY:TEST EQUIPMENT USED: Default Administrator
1 InternalNumber of Cells:
VOLTAGE/CAPACITY VS. TIME
VOLTAGE:STOPVOLTAGE:WARNINGCAPACITY: STOPCAPACITY: WARNING____CAPACITY:MEASURED VOLTAGE:MEASURED_ _ _ ___ _______ _ _ _
Ah Change to Log:
Update Interval (Minutes):
TORKEL
0.25
0.050 10
Show Test Data:
Voltage Change to Log:
Preferred Tolerance:
COMMENTS:
DEFICIENCIES:
BATTERY TEST
5
BATTERY FORMS
10/10/2014
BATTERIES
PLANT
AUTOMATED
°FExample Plant
Example OwnerOWNER
%
ASSET ID
HUMIDITY
AMBIENT TEMP.
JOB #
DATE
PAGE
POSITION
SUBSTATION
10760, REVISED 7/13/2012COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
TESTED BY:TEST EQUIPMENT USED: Default Administrator
HIGH RESISTANCE LIMIT (µOhm)LIMITS:
1 2 3 4
HIGH VOLTAGE LIMIT (V): HIGH TEMPERATURE LIMIT (°F)
LOW SPECIFIC GRAVITY LIMITLOW TEMPERATURE LIMIT (°F)LOW RESISTANCE LIMIT (µOhm)
STRING NAME: BATTERY NAME:
MODEL NUMBER:
INSTALLATION DATE:
INTERCELL RESISTANCE THRESHOLD VALUES (µOhm)
LOW VOLTAGE LIMIT (V):
HIGH SPECIFIC GRAVITY LIMIT
NUMBER OF CELLS:
3
INTERCELL RESISTANCE (micro-ohms)
1 2 4
CELL DATA
NOTES
MAX. VOLTAGE: AVG. SPEC. GR.:AVG. VOLTAGE:AVG. RESISTANCE: MIN. VOLTAGE: AVG. TEMP.:
CELL No.
VOLTAGE (volts)
RESISTANCE (micro-ohms)
SPECIFIC GRAVITY
TEMP.
°F
COMMENTS:
DEFICIENCIES:
BATTERY DISCHARGE TEST
6
BATTERY FORMS
10/10/2014
BATTERIES
PLANT
AUTOMATED
°FExample Plant
Example OwnerOWNER
%
ASSET ID
HUMIDITY
AMBIENT TEMP.
JOB #
DATE
PAGE
POSITION
SUBSTATION
10757, REVISED 2/7/2014COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
TESTED BY:TEST EQUIPMENT USED: Default Administrator
Update Interval
4 4
Number of BVM Sets: One Set
Number of Cells:
First Cell Starts At: 1 5
Number of Cells:
First Cell Starts At:
Data Collection Mode: Update Interval (Sec):
BVM Settings
BVM Status
Show Total Volt. Graph:First BVM Set Second BVM Set
Cells Outside Limits:
Show Data Table:
Show Bar Graph:
30
Total Voltage vs. Time
___VOLTAGE:MEASURED
BVM Data (HH:MM:SS)
60%
(00:36:00)50%
(00:30:00)25%
(00:15:00)0%
(00:00:00)Float
Voltage100%
(01:00:00)90%
(00:54:00)Last Value Fail Time Fail %
80% (00:48:00)
70% (00:42:00)
Cell DataCell
Number
0.0000.000 0.000 0.0000.0000.0000.0000.0000.0000.000Total Volt.
1
2
BATTERY DISCHARGE TEST
7PAGE
10757, REVISED 2/7/2014COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
BVM Data (HH:MM:SS)
60%
(00:36:00)50%
(00:30:00)25%
(00:15:00)0%
(00:00:00)Float
Voltage100%
(01:00:00)90%
(00:54:00)Last Value Fail Time Fail %
80% (00:48:00)
70% (00:42:00)
Cell DataCell
Number
0.0000.000 0.000 0.0000.0000.0000.0000.0000.0000.000Total Volt.
3
4
COMMENTS:
DEFICIENCIES:
BATTERY TEST
8
BATTERY FORMS
10/10/2014
BATTERIES
PLANT
AUTOMATED
°FExample Plant
Example OwnerOWNER
%
ASSET ID
HUMIDITY
AMBIENT TEMP.
JOB #
DATE
PAGE
POSITION
SUBSTATION
10750, REVISED 12/17/2013COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
TESTED BY:TEST EQUIPMENT USED: Default Administrator
0for
DUTY CYCLE: 0 AmpsSTRING NAME:
NUMBER OF STRAPS:
1to
AUTOMATED
01
/1 VPC
Minutes
NUMBER OF CELLS / JAR:HYDROMETER. START/SKIP CELLS:
NOMINAL: 2.2VOLTS PER CELL:
NUMBER OF CELLS:
STRING
INSTALLATION DATE:
Amps
VoltsVOLTAGE:
CURRENT:
EQUALIZATION VOLTAGE: Volts
MANUFACTURER:
MODEL:
FLOAT CURRENT:
RIPPLE CURRENT:
TOTAL AC CURRENT:
CHARGER
VARIATION WARNING (%):
VARIATION ALARM (%):
5.0
10.0
DEVIATION WARNING (%):
DEVIATION ALARM (%): CHANGE ALARM (%):
CHANGE WARNING (%): STRAP WARNING (%):
STRAP ALARM (%):
LIMITS: LOW VOLTAGE LIMIT (V):
HIGH VOLTAGE LIMIT (V):
IMPEDANCE (milli-ohms)
NOTESVALUE
% DEVIATION (Baseline)
% VARIATION (String)
% CHANGE (Prev.)
VOLTAGE (volts) TIME MODEL
SPECIFIC GRAVITY
CELL No.
CELL DATA CELL DATA
#
Min. Voltage:Avg. Impedance: Total String Voltage: Dev. from Charger: %Baseline Impedance: Max. Voltage:
TEMP.
°C
Milli-OhmsDisplay Impedance:
0.000
TYPESTRAP #% VARIATION
(Avg)
CELL CONNECTED TO
MEASUREMENT TIME
Avg. Strap Resistance: Display resistance in: Micro-Ohms
RESISTANCE(micro-ohms)
01
COMMENTS:
DEFICIENCIES:
SITE:
SEND STRINGS TO BITE3
REVISED 7/7/2010COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
STRING NAME:
1. Enter "STRING NAME" and "SITE" and Click "SEND TO BITE3"2. Wait till the information is sent to the BITE3 before sending another string.
SEND TO BITE3
°CVDC
UPS BATTERY DISCHARGE
10
BATTERY FORMS
10/10/2014
BATTERIES
PLANT
GENERAL
°FExample Plant
Example OwnerOWNER
%
ASSET ID
HUMIDITY
AMBIENT TEMP.
JOB #
DATE
PAGE
POSITION
SUBSTATION
TEMPERATURE CORRECTED CURRENT
CELL VOLTAGE ALARM
CELL VOLTAGE DEVIATION ALARM
CELL VOLTAGE SHUTDOWN LEVEL
BATTERY VOLTAGE ALARM
BATTERY VOLTAGE SHUTDOWN LEVEL
MFR.'S RATED CAPACITY - MINUTES
ACTUAL DISCHARGE - MINUTES
PERCENTAGE BATTERY CAPACITY
10500, REVISED 5/26/2010COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
TESTED BY:TEST EQUIPMENT USED: Default Administrator
UPS NAMEPLATE DATA
%
BATTERY NAMEPLATE DATA
TEST PARAMETERS
MANUFACTURER
CATALOG NO.
INPUT VOLTAGE
DC VOLTAGE INPUT
VOLTAGE OUTPUT
OTHER
kVA RATING
INPUT CURRENT
DC INPUT CURRENT
CURRENT OUTPUT
MODEL
POWER FACTOR
INPUT FREQUENCY
OUTPUT FREQUENCY
SERIAL NO.
TYPE STATIC ROTARY
OUTPUT PHASE
INPUT PHASE
MANUFACTURER
CATALOG NO.
OVERALL BATTERY VOLTAGE
OTHER
CELL TYPE
SPECIFIC GRAVITY RANGE
NUMBER OF CELLS
CELL VOLTAGE
AMP HOUR RTG
BATTERY TEMP
COMMENTS:
DEFICIENCIES:
°C VDC
MANUFACTURER'S
DISCHARGE RATE
END CELL VOLTAGETEST CURRENT OVERALL END BATTERY VOLTAGE TIME
10000, REVISED 6/22/2010COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
TESTED BY:TEST EQUIPMENT USED: Default Administrator
CATALOG NO.
BATTERY DISCHARGE TEST
11
BATTERY FORMS
10/10/2014
BATTERIES
PLANT
GENERAL
°FExample Plant
Example OwnerOWNER
%
ASSET ID
HUMIDITY
AMBIENT TEMP.
JOB #
DATE
PAGE
POSITION
SUBSTATION
MA
MFR'S RATED CAPACITY TIME - MINUTES
ACTUAL DISCHARGE TIME - MINUTES
BATTERY CAPACITY - PERCENT
TEMPERATURE CORRECTED CURRENT
CELL VOLTAGE ALARM
CELL VOLTAGE DEVIATION ALARM
CELL VOLTAGE SHUTDOWN LEVEL
BATTERY VOLTAGE ALARM
BATTERY VOLTAGE SHUTDOWN LEVEL
MANUFACTURER
OVERALL BATTERY VOLTAGE
OTHER
BATTERY CHARGE STATUS: CHARGED EQUALIZED
CELL TYPE
SPECIFIC GRAVITY RANGE
NUMBER OF CELLS
CELL VOLTAGE
AMP HOUR RATING
BATTERY TEMP.
TEST PARAMETERS
NAMEPLATE DATA
COMMENTS:
DEFICIENCIES:
BATTERY INSPECTION
SPECIFIC GRAVITY
12
BATTERY FORMS
10/10/2014
BATTERIES
PLANT
GENERAL
°FExample Plant
Example OwnerOWNER
%
ASSET ID
HUMIDITY
AMBIENT TEMP.
JOB #
DATE
PAGE
POSITION
SUBSTATION
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
SPEC. GRAVITY VOLTAGE
34
35
36
37
38
39
40
REVISED 5/26/2010COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
°C
CELL
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
SPEC. GRAVITY VOLTAGE
74
75
76
77
78
79
80
CELL
41
NAMEPLATE DATA
MANUFACTURER
CATALOG NO.
OVERALL BATTERY VOLTAGE VDC
BATTERY TEMP.
OTHER
BATTERY CHARGE STATUS CHARGED DISCHARGED EQUALIZED TEMPERATURE CORRECTED READINGS YES NO
AMP HOUR RATING
CELL VOLTAGE CELL TYPE
SPECIFIC GRAVITY RANGE
NUMBER OF CELLS
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
SPEC. GRAVITY VOLTAGECELL
81
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
103
120
121
122
123
124
125
126
127
128
129
130
119
82
133
134
135
136
137
138
139
140
141
142
143
144
145
146
147
148
149
150
151
152
SPEC. GRAVITY VOLTAGECELL
131
154
155
156
157
158
159
160
161
162
163
164
165
166
167
168
153
170
171
172
173
174
175
176
177
178
179
180
169
132
83
BATTERY INSPECTION
SPECIFIC GRAVITY
13PAGE
REVISED 5/26/2010COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
CELL NO. TEMP. °CTEMP. °C CELL NO. TEMP. °C CELL NO.
186
187
188
189
190
191
192
193
194
195
196
197
198
199
200
201
202
SPEC. GRAVITY VOLTAGECELL
181
204
205
206
207
208
209
210
211
212
213
214
215
216
217
218
203
220
221
222
223
224
225
219
182
183
229
230
231
232
233
234
235
236
237
238
239
240
241
242
243
244
245
246
247
SPEC. GRAVITY VOLTAGECELL
226
249
250
251
252
253
254
255
256
257
258
259
260
261
262
263
248
265
266
267
268
269
270
264
227
228
REVISED 5/26/2010COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
TESTED BY:TEST EQUIPMENT USED: Default Administrator
184
185
BATTERY INSPECTION
SPECIFIC GRAVITY
14PAGE
PILOT CELLS
COMMENTS:
DEFICIENCIES:
EQUALIZATION VOLTAGEMODEL
OTHER
CURRENT Amps VOLTAGE Volts
Volts
MANUFACTURER
CHARGER DATA
BATTERY INSPECTION REPORT
15
BATTERY FORMS
10/10/2014
BATTERIES
PLANT
GENERAL
°FExample Plant
Example OwnerOWNER
%
ASSET ID
HUMIDITY
AMBIENT TEMP.
JOB #
DATE
PAGE
POSITION
SUBSTATION
MANUFACTURER
CATALOG NO.
OTHER
BATTERY DATA
-
MODEL
SPEC. GRAVITY RANGE (g/cm3)
OVERALL BATTERY VOLTAGE (V)
CAPACITY RATING (Ah)
COMMISSION DATE0NUMBER OF CELLS
CONDITIONINSPECTED
CELL VOLTAGE (V)
DESCRIPTION
VENTILATION OF ROOM OR ENCLOSURE
EYEWASH EQUIPMENT
PHYSICAL AND MECHANICAL CONDITION
ANCHORAGE, ALIGNMENT AND GROUNDING
ELECTROLYTE LEVEL
FLAME ARRESTERS
SUPPORT RACKS, MOUNTING, CLEARANCES
NEUTRALIZE ACID ON EXTERIOR SURFACES
CLEAN CORRODED/OXIDIZED TERMINALS
CONDITIONINSPECTEDDESCRIPTION
PHYSICAL AND MECHANICAL CONDITION
ANCHORAGE, ALIGNMENT AND GROUNDING
CLEAN AND REMOVE DEBRIS
FILTER AND TANK CAPACITORS
COOLING FANS, VERIFY OPERATION
CLEAN OR REPLACE FILTERS
BOLTED ELECTRICAL CONNECTIONS
FUNCTIONS AND ALARMS
BATTERY INSPECTION CHARGER INSPECTION
10050, REVISED 9/6/2012COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
TESTED BY:TEST EQUIPMENT USED: Default Administrator
BATTERY CASE/ENCLOSURE
# OF RACKS 11
VDC A ATotal AC CurrentOverall Voltage Float Current AC Ripple CurrentADC
Positive Terminal to Gnd. VDC NegativeTerminal to Gnd. VDC
STRING MEASUREMENTS
GROUND TEST
COMMENTS:
DEFICIENCIES:
BATTERY INSPECTION
RESISTANCE
16
BATTERY FORMS
10/10/2014
BATTERIES
PLANT
GENERAL
°FExample Plant
Example OwnerOWNER
%
ASSET ID
HUMIDITY
AMBIENT TEMP.
JOB #
DATE
PAGE
POSITION
SUBSTATION
RESISTANCE ( µ )
10200, REVISED 5/26/2010COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
°C
RESISTANCE ( µ ) VOLTAGE DROP (mV)
NAMEPLATE DATA
MANUFACTURER
CATALOG NO.
OVERALL BATTERY VOLTAGE VDC
BATTERY TEMP.
OTHER
BATTERY CHARGE STATUS CHARGED DISCHARGED EQUALIZED TEMPERATURE CORRECTED READINGS YES NO
AMP HOUR RATING
CELL VOLTAGE CELL TYPE
SPECIFIC GRAVITY RANGE
NUMBER OF CELLS
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31
32
33
34
35
36
37
38
39
40
41
42
43
44
45
46
47
48
49
50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
VOLTAGE DROP (mV) CURRENT (A) CURRENT (A)CELLCELL Ω Ω
RESISTANCE ( µ ) VOLTAGE DROP (mV) RESISTANCE ( µ ) VOLTAGE DROP (mV)
BATTERY INSPECTION
RESISTANCE
17PAGE
10200, REVISED 5/26/2010COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
81
82
83
84
85
86
87
88
89
90
91
92
93
94
95
96
97
98
99
100
101
102
103
104
105
106
107
108
109
110
111
112
113
114
115
116
117
118
119
120
121
122
123
124
125
126
127
128
129
130
CELL CURRENT (A)
131
132
133
134
135
136
137
138
139
140
141
142
143
144
145
146
147
148
149
150
151
152
153
154
155
156
157
158
159
160
161
162
163
164
165
166
167
168
169
170
171
172
173
174
175
176
177
178
179
180
CURRENT (A)CELLΩ Ω
CELL NO. TEMP. °CTEMP. °C CELL NO. TEMP. °C CELL NO.
RESISTANCE ( µ ) VOLTAGE DROP (mV) RESISTANCE ( µ ) VOLTAGE DROP (mV)
10200, REVISED 5/26/2010COPYRIGHT © 2002-2014 POWERDB, INC. www.powerdb.com
TESTED BY:TEST EQUIPMENT USED: Default Administrator
BATTERY INSPECTION
RESISTANCE
18PAGE
PILOT CELLS
181
182
183
184
185
186
187
188
189
190
191
192
193
194
195
196
197
198
199
200
201
202
203
204
205
206
207
208
209
210
211
212
213
214
215
216
217
218
219
220
221
222
223
224
225
CELL CURRENT (A)
226
227
228
229
230
231
232
233
234
235
236
237
238
239
240
241
242
243
244
245
246
247
248
249
250
251
252
253
254
255
256
257
258
259
260
261
262
263
264
265
266
267
268
269
270
CELL CURRENT (A)Ω Ω
COMMENTS:
DEFICIENCIES:
