www.bluechemgroup.com

Automatic Transmission Service

power

How?

Automatic Transmission CleaningModern automatic transmission fluids should be replaced at least every 50-60,000 km according to the manufacturers’ specifications. Some manufacturers even do not instruct change intervals. This is a so-called lifetime filling.

However, even in compliance with the oil change intervals, damages or defects can occur. In contrast to manual transmissions, automatic transmission wear out considerably faster. By increasing wear and soiling of clutch plates and solenoid valves, the function of the transmission deteriorates gradually without the motorist being aware of this. Only when the performance of the transmission is significantly impaired, the costly damage is perceived.

To avoid that, a cleaning of the automatic transmission system is recommended by more and more manufacturers. This service prevents costly repairs, helps with loss of power and restores a smooth/quiet gear operation.

With a conventional oil change, not all contaminants can be removed from automatic transmissions. Approx. 60% of the waste oil remain in the gearbox. About 90% of all installed automatic transmission are concerned by this, because only the part of waste oil is removed, which is located in the oil pan. All other components such as heat exchangers and pipes, but especially the converter cannot be emptied.

If the electrical and mechanical problems have caused no damage, the ATF EVOLUTION PREMIUM in combination with our products helps usually immediately. This automatic transmission service allows a complete replacement of the transmission fluid and a thorough cleaning of the transmission system in simple steps. The oil change for transmission, torque converter, exchangers and pipes is carried out within a short time. The exchange rate is almost 100%.

The success of cleaning is immediately evident: the running is quieter, any bucking disappears and the gears are switching smooth and soft again.

We recommend the preventive use, to avoid damage.

Why?

www.bluechemgroup.com

The Automatic Transmission Cleaning results in:

• Complete removal of contaminants in the entire transmission system

• Noise reduction

• Safe and smooth gear running

• Optimized gear changing behavior

• Avoidance of costly repairs

Cleaning and maintenance of the entire transmission system: easily and quickly with just one device.

The ATF EVOLUTION PREMIUM offers a range of automatic functions that supply the transmission expert with a simple tool to exchange the transmission fluid. The ATF EVOLUTION PREMIUM may be used in a manu-al operation as well.

ATF EVOLUTION PREMIUMCleaning and service devicefor Automatic Transmissions

AUCH FÜR ALSO WORKS WIT

H DSG

www.bluechemgroup.com

Functions

• Flushing the AT systems (automatic transmission, torque converter, cooler and pipes)

• Oil exchange and level adjustment

• Print out the procedure and the vehicle data

• Monitoring temperature

• Monitoring oil pressure

• Customizable database

ATF EVOLUTION PREMIUMCleaning and service devicefor Automatic Transmissions

Accessoiries

The standard adapter set for automatic transmissions of various vehicle manufacturers is included in the delivery contents.

The optional adapter set contains additional adapters for the brands Audi, BMW, Chrysler, Fiat, Ford, GM, Honda, Hummer, Lexus, Mercedes, Mitsubishi, Opel, Toyota, Volkswagen and Volvo.

Characteristics

• LCD display and compact design makes operation easy

• Automatic filling of automatic transmission fluid

• Automatic identification of the power polarity

• Automatic and intelligent switching of the fluid flow in and out

• Automatically circulated cleaning function for automatic transmissions

• Automatic exchange of new and used fluid

• Visual display the fluid pressure of A/F radiator and the fluid outlet pressure of the unit

• Intelligent electronic control of the full automatic amount of liquid exchanged of new and used fluid

• It improves the performance of the transmission, and it prolongs the working life of the AT system.

• Because of the compact design, the device is flexible and perfectly suited to the needs of any workshop

• Warranty 12 months

Device ATF EVOLUTION PREMIUM

Optional accessories available on request.PU 1 pc.

Art.-No. 34090-1

www.bluechemgroup.com

Specifications• Power Supply: AC

220V/50Hz or AC 110/60Hz

• Maximum Power: 150W

• Pressure gauge: 0–200psi

• Fluid outlet hose: 2.5m

• Fluid return hose: 2,5m

• Fluid draining hose: 1,2m

• Filtration: 5μm

• Fluid tank: 2 x 20 ltr

• Equivalent exchange error: +/- 100ml

• Noise: <70db

• Weight: 78kg

ATF EVOLUTION PREMIUMAdapter / Accessoiries

A list of available adapters incl. vehicle types is available on request.

www.bluechemgroup.com

STANDARD KIT (inclusive)

Contains adapter for:

Toyota, Mitsubishi, Lexus, Honda, Nissan, Cadillac, BMW, general european vehicles, Chrysler, Ford, General Motors, Volvo, Daimler Benz and universal adapter

ADAPTER KIT I

Contains adapter for:

Dodge, AISIN, Peugeot, Renault, Citroen, Fiat, Opel, VAG, Audi, VW, Seat, Skoda, BMW, Mercedes Benz, Hummer, Saab and Porsche

ADAPTER KIT II

Contains adapter for:

Chrysler, Dodge, Ford, Toyota, Honda, Nissan, Mitsubishi, Lexus, special adapter and adapter for hoses

ADAPTER KIT III

Contains adapter for:

Alfa Romeo, Fiat, GM, Buick, Chevrolet, Cadillac, Saab, Chrysler, Volvo, Lincoln, Mazda, Ford and universal adapter

Clean and maintain the

automatic transmission

effectively, rapidly and

cheaply.

Cleaning andCare Products

Reliably dissolves and removes contaminants, such as oxidised oil residues and other deposits from the entire transmission oil system. Smooth and powerful gear changing will be the result. For all cars with automatic transmission.

Application: Add the product to the oil system before exchanging the transmission oil. Run the system for approx. 10-15 minutes under frequent load change. Afterwards carry out the exchange of the transmission oil according to the manufacturer’s instructions.

Content 375 ml 1 ltr 5 ltr 10 ltr 20 ltr 200 ltr

PU 28 pc. 12 pc. 4 pc. 1 pc. 1 pc. 1 pc.

PRO-TEC Art.-No. P1701 P1709 P1702 P1708 P1707 P1705

bluechem Art.-No. 33179 — 33175 33174 33173 33172

Automatic Transmission Flush

For the preservation of seals and o-rings. Reduces formation of foam and oxidation. Automatic Transmission Conditioner extends durability and delays the buildup of new residues of resin and similar contaminants. For all cars with automatic transmission.

Application: Add to the gear oil system.

Content 375 ml 1 ltr 5 ltr 10 ltr 20 ltr 200 ltr

PU 28 pc. 12 pc. 4 pc. 1pc. 1 pc. 1 pc.

PRO-TEC Art.-No. P1801 P1809 P1802 P1808 P1807 P1805

bluechem Art.-No. 33178 — 33176 33177 33171 33170

Automatic Transmission Conditioner

www.maxxpower.info Ready for use, around the globe.

Automatic Transmission Fluidspower

maxxpower® premiumATF 3

ATF 3 is used in automatic transmissions, power steering systems, fluid couplings, hydrodynamic converters and hydraulics in cars, trucks, buses and construction vehicles, if the manufacturer‘s specifications requires an ATF Type Dexron III H.

Recommended for vehicles that require an oil to the following classifications / specifications:

• Allison C-4 • Allison TES, 389 • DEXRON III H

•DEXRON III G • Ford M2C138-CJ, M2C 166-H • Ford Mercon

• MAN 339 Typ Z1 & V1, Z2 & V2 • MB 236.1, 236.5, 236.6 & 236.7 • Voith 55.6335 & 55.6336

• Volvo 97340, 97341 • ZF TE-ML 02F, 04D, 09,11A, 14A & 17C

Content 1 ltr 5 ltr 20 ltr

PU 12 pc. 3 pc. 1 pc.

Art.-No. 36900 36901 36902

Ready for use, around the globe.

maxxpower® premiumATF 4

maxxpower® premiumATF 6

ATF 4 is used in automatic transmissions, power steering systems, fluid couplings, hydrodynamic converters and hydraulics, if the manufacturer‘s specifications requires an ATF Type 4. Exceeds all Dexron III-requirements an is easily miscible with all Dexron II D- and Dexron III ATFs.

ATF 6 is a synthetic high-performance automatic transmission fluid which consists of versatile components of the especially for vehicles optimized „anti-shudder“ additive technology.

Characterized by low foaming tendencies and exceptionally stable oxidation behavior.

Recommended for vehicles that require an oil to the following classifications / specifications:

• DEXRON III

• Voith Turbo according to H55.6336.35 for extended oil change intervals (120.000 km)

• ZF TE-ML 11B

Recommended for vehicles that require an oil to the following classifications / specifications:

• Allison C-4/ TES-295 • Ford Mercon® -V • GM Type A Suffix A

• GM Dexron®-IID/-IIE/-IIIG/-IIIH • GM Dexron®-VI (does not meet the level of viscosity)

• JASO 1-A • MAN 339 Type V-1&2/Z-1&2 • Volvo 97340 + 97341

• MB 236.1, 236.2, 236.5, 236.6, 236.7, 236.9, 236.1 0, 236.11 • Chrysler ATF +3/+4

• ZF TE-ML 02F, 03D, 04D, 05L, 09, 11B, 14A, 14B, 16L, 17C • Audi G 052 025, /G-052-162

• BMW LA2634/ LT 71141/ 5 Series/ ETL-8072B/ BMW 7045E • Daimler NAG 1

• Volvo 4-6 Speed • VW TL52162 • ATF-MV

Content 1 ltr 5 ltr 20 ltr

PU 12 pc. 3 pc. 1 pc.

Art.-No. 36910 36911 36912

Content 1 ltr 5 ltr 20 ltr

PU 12 pc. 3 pc. 1 pc.

Art.-No. 36920 36921 36922

www.maxxpower.info

Automatic Transmission Fluidspower

maxxpower® premiumDSG+

maxxpower® premiumCVT+

DSG+ is a synthetic high-performance automatic transmission fluid developed specifically for use in the latest generation of DSG gearboxes. Neutral to metals and sealing materials and offers excellent viscosity-temperature behavior.

Please refer to vehicle manufacturer recommended specifications prior to use.

Recommended for vehicles that require an oil to the following classifications / specifications:

• Audi / VW / Seat / Skoda - DQ250 / DQ500 / DL501 (VW TL 052 182) • BMW - 7DCI600 / DCI700

• Citroen / Nissan / Peugeot - 6DCT451 (Peugot/Citroen 9734.52) • Mitsubishi - 6DCT470

• Ford / Getrag - 6DCT450 / 6DCT451 / 7DCT300 (Ford M2C936A) • Volvo - 6DCT40

• Mercedes Benz - F-DCT350 / F-DCT500

• Porsche - ZF 7DT45HL / 7DT45HLA / 7DT45F / 7DFL / 7DT70HLA / 7DT75 / 7DT75A

Content 1 ltr 5 ltr 20 ltr

PU 12 pc. 3 pc. 1 pc.

Art.-No. 36930 36931 36932

High-performance special transmission fluid designed for cartronic transmissions, such as used in Mercedes A and B Class and many other variable automatic transmission by various car manufacturers (e.g. Audi Multitronic).

Recommended for vehicles that require an oil to the following classifications / specifications:

• Nissan NS-II • Hyundai / Kia SP-III • Mopar CVTF+4

• Suzuki TC/NS-II • Daihatsu TC • Toyota

• GM / Saturn DEX-CVT • Mitsubishi NS-II / SP-III/ CVT J-1 • Honda ATF-Z1

• Ford CVT 23 / WSS-M2C928-A • BMW 8322 0 136 376 / 8322 0 429 159

• Honda HMMF • Subaru • MB 236.20

• MB A 001 989 46 03 • VW G 052 180 • JASO M358

Content 1 ltr 5 ltr 20 ltr

PU 12 pc. 3 pc. 1 pc.

Art.-No. 36940 36941 36942

Recommended by

Art.-No.. 34109-2

03/2016 | © 2016 bluechemGROUP

Subject to modifications and errors. Similar image.

Picture material: Page 1 - fotolia_22431701 | Page 2 - © leonello calvetti-CutawayCar-91924364-shutterstock.com | Page 2 - Automatic transmission © popov48 #42106135-fotolia.com | Page 8 - boite de vitesses d‘une automobile © PackShot #34408763 - fotolia.com | Page 11 - Motor oil poring © Georgi Roshkov - Fotolia.com

CTP GmbHSaalfelder Str. 35 h07338 LeutenbergGermany

Phone +49 (0)36734 230-0Fax +49 (0)36734 230-22info@bluechemgroup.comwww.bluechemgroup.com