ANUFACTURING OF YELLOW GLOBEX LABORATORIES (R&D) LTD …gpcb.gov.in/pdf/Globex_Annexures.pdf · Annexure 1: Application Letter for EC . ... Project site location along with site map

GLOBEX LABORATORIES (R&D) LTD. �ANUFACTURING OF YELLOW PIGMENTS AND RED PIGMENTS ANNEXURE

KADAM ENVIRONMENTAL CONSULTANTS 185 APRIL 2011

Annexure 1: Application Letter for EC

GLOBEX LABORATORIES (R&D) LTD. MANUFACTURING OF YELLOW PIGMENTS AND RED PIGMENTS ANNEXURE


Annexure 2: TOR Letter F. No. J-11011/95/2010- IA II (I)

Government of India Ministry of Environment and Forests

(I.A. Division) Paryavaran Bhawan

CGO Complex, Lodhi Road New Delhi – 110 003

E-mail : [email protected]

Telefax : 011: 2436 7668 Dated 9th August, 2010

To, Shri Neerav Goswamy, Director, M/s Globex Laboratories (R & D) Ltd, D-502, Nisarg, Diwalipura Old Padra Road, District Vadodara-390001, Gujarat. E-mail : [email protected]; Fax No. : 265-2633972 Subject : Red Pigments (40 MTPM) and Yellow Pigments (40 MTPM)

Manufacturing Unit at Old Survey No. 81/2, Block No. 142, Village Dabhasa, Taluka Padra, District Vadodara, Gujarat by M/s Globex Laboratories (R & D) Ltd. - TORs reg.

Ref. : Your letter no. nil dated 10th February, 2010.

Sir, Kindly refer your letter no. nil dated 10th February, 2010 alongwith project

documents including Form-I, Pre-feasibility Report and draft ‘Terms of Reference’ as per the EIA Notification, 2006. It is noted that proposal is for the Red Pigments (40 MTPM) and Yellow Pigments (40 MTPM) Manufacturing Unit at Old Survey No. 81/2, Block No. 142, Village Dabhasa, Taluka Padra, District Vadodara, Gujarat by M/s Globex Laboratories (R & D) Ltd. Following products will be manufactured:

S.N. Products Capacity (MTPM) 1 Yellow Pigments (Powder/cake/dispersion /preparation) 40 2 Red Pigments (Powder/cake/dispersion /preparation) 40

Draft Terms of Reference (TOR) have been discussed and finalized during the 12th Expert Appraisal Committee (Industry-2) meeting held on 15th–16th July, 2010 for preparation of EIA/EMP. Following are the ‘TORs’:

1. Executive summary of the project 2. Justification of the project. 3. Promoters and their back ground 4. Regulatory framework 5. Project location and plant layout. 6. Infrastructure facilities including power sources.



7. Total cost of the project alongwith total capital cost and recurring cost/annum for environmental pollution control measures.

8. Project site location along with site map of 10 km area and site details providing various industries, surface water bodies, forests etc.

9. Present land use based on satellite imagery for the study area of 10 km radius. Location of National Park/Wild life sanctuary/Reserve Forest within 10 km radius of the project.

10. Details of the total land and break-up of the land use for green belt and other uses.

11. Site-specific micro-meteorological data using temperature, relative humidity, hourly wind speed and direction and rainfall is necessary.

12. List of raw materials, products alongwith the production capacities and list of solvents and its recovery plan.

13. Commitment for not using azodyes in the process should be given. 14. Detailed list of raw material required and source, mode of storage and

transportation. 15. Manufacturing process details alongwith the chemical reactions. 16. Design details of ETP, incinerator, if any alngwith control of Dioxin & Furan,

boiler, scrubbers/bag filters etc. 17. Details of water and air pollution and its mitigation plan 18. Ambient air quality for all the parameters including VOCs within the study

area of 5 km., aerial coverage from project site. Location of one AAQMS in downwind direction.

19. Ambient air quality modelling for plant. 20. Action plan to control ambient air quality as per NAAQES Standards notified by the

Ministry on 16th September, 2009. 21. One season site-specific micro-meteorological data using temperature, relative

humidity, hourly wind speed and direction and rainfall and AAQ data (except monsoon) for PM10, SO2, NOx including HC and VOCs.should be collected. The monitoring stations should take into account the pre-dominant wind direction, population zone and sensitive receptors including reserved forests. Data for water and noise monitoring should also be included.

22. An action plan to control and monitor secondary fugitive emissions from all the sources as per the latest permissible limits issued by the Ministry vide G.S.R. 414(E) dated 30th May, 2008.

23. Determination of atmospheric inversion level at the project site and assessment of ground level concentration of pollutants from the stack emission based on site-specific meteorological features.

24. Permission for drawl of 180 m3/day water from the CGWA/SGWB/concerned authority. Water balance cycle data including quantity of effluent generated recycled and reused and discharged.

25. Ground water monitoring minimum at 6 locations should be carried out. Geological features and Geo-hydrological status of the study area and ecological status (Terrestrial and Aquatic).

26. The details of solid and hazardous wastes generation, storage, utilization and disposal particularly related to the hazardous waste calorific value of hazardous waste and detailed characteristic of the hazardous waste.

27. Details of land fill as per CPCB guidelines 28. Location of secured land fill/TSDF alongwith design details. 29. Authorization/Membership details of the EICL, Umaraya for the disposal of

liquid effluent and TSDF, M/s NECL, Umaraya for the disposal of solid waste/hazardous waste.



30. Ground water monitoring around the land fill site 31. Risk assessment for storage for chemicals/solvents and phosgenes. 32. An action plan to develop green belt in 33 % area 33. Action plan for rainwater harvesting measures at plant site should be included

to harvest rainwater from the roof tops and storm water drains to recharge the ground water.

34. Occupational health of the workers needs elaboration including evaluation of noise, heat, illumination, dust, any other chemicals, metals being suspected in environment and going into body of workers either through inhalation, ingestion or through skin absorption and steps taken to avoid musculo-skeletal disorders (MSD), backache, pain in minor and major joints, fatigue etc. Occupational hazards specific pre-placement and periodical monitoring should be carried out.

35. Socio economic development activities should be in place. 36. Note on compliance to the recommendations mentioned in the CREP

guidelines. 37. Detailed Environment management Plan (EMP) with specific reference to

details of air pollution control system, water & wastewater management, monitoring frequency, responsibility and time bound implementation plan for mitigation measure should be provided.

38. EMP should include the concept of waste-minimization, recycle/reuse/recover techniques, Energy conservation, and natural resource conservation.

39. Name and location of the TSDF alongwith membership should be incorporated.

40. Total capital cost and recurring cost/annum for environmental pollution control measures.

41. Any litigation pending against the project and/or any direction/order passed by any Court of Law against the project, if so, details thereof.

42. Public hearing issues raised and commitments made by the project proponent on the same should be included separately in EIA/EMP Report in the form of tabular chart with financial budget for complying with the commitments made.

43. A tabular chart with index for point wise compliance of above TORs. The following general points should be noted:

(i) All documents should be properly indexed, page numbered. (ii) Period/date of data collection should be clearly indicated. (iii) Authenticated English translation of all material provided in Regional

languages. (iv) The letter/application for EC should quote the MOEF file No. and also

attach a copy of the letter. (v) The copy of the letter received from the Ministry should be also attached as

an annexure to the final EIA-EMP Report. (vi) The final EIA-EMP report submitted to the Ministry must incorporate the

issues in this letter. The index of the final EIA-EMP report must indicate the specific chapter and page no. of the EIA-EMP Report.

(vii) While preparing the EIA report, the instructions for the proponents and instructions for the consultants issued by MoEF vide O.M. No. J-11013/41/2006-IA.II (I) dated 4th August, 2009, which are available on the website of this Ministry should also be followed.



(viii) The consultants involved in the preparation of EIA/EMP report after accreditation with Quality Council of India (OCl)/National Accreditation Board of Education and Training (NABET) would need to include a certificate in this regard in the EIA/EMP reports prepared by them and data provided by other organization/Laboratories including their status of approvals etc. In this regard circular no F. No. J -l1013/77/2004-IA II(I) dated 2nd December, 2009 posted on the Ministry’s website http://www.moef.nic.in may be referred.

(ix) ‘Certificate of Accreditation’ issued by the QCI to the environmental consultant should be included.

These ‘TORs’ should be considered for the preparation of EIA / EMP report

for the Red Pigments (40 MTPM) and Yellow Pigments (40 MTPM) Manufacturing Unit at Old Survey No. 81/2, Block No. 142, Village Dabhasa, Taluka Padra, District Vadodara, Gujarat in addition to all the relevant information as per the ‘General Structure of EIA’ given in Appendix III and IIIA in the EIA Notification, 2006. The EIA/EMP as per TORs should be submitted to the Chairman, Gujarat Pollution Control Board (GPCB), Gujarat for public consultation. The GPCB shall conduct the public hearing/public consultation as per the provisions of EIA notification, 2006. You are requested to kindly submit the final EIA/EMP prepared as per TORs and incorporating all the issues raised during Public Hearing / Public Consultation to the Ministry for considering the proposal for environmental clearance within 2 years as per the MoEF O.M. No. J-11013/41/2006-IA.II (I) dated 22nd March, 2010. The consultants involved in the preparation of EIA/EMP report after accreditation with Quality Council of India / National Accreditation Board of Education and Training (QCI/NABET) would need to include a certificate in this regard in the EIA/EMP reports prepared by them and data provided by other Organization(s)/Laboratories including their status of approvals etc. In this regard circular no F. No. J -l1013/77/2004-IA II(I) dated 2nd December, 2009 available on the Ministry’s website http://www.moef.nic.in may be referred. (Dr. P.B. Rastogi)

Scientist ‘F’ Copy to : The Chairman, Gujarat Pollution Control Board, Paryavaran Bhavan, Sector – 10,

A, Gandhi Nagar - 382 010, Gujarat



Annexure 3: Ambient Air Quality Monitoring Results

Station Code Sampling Date Average Pollutant Concentration (µg/m3) (mg/m3)

RSPM (24hr.) SO2 (24hr.) NOx

(24hr) THC

(Grab) NMHC (Grab) VOC's (Grab)

Residential 100 80 80 Not Specified Industrial 150 120 120

Sensitive 75 30 30 A1 21st Dec '09 36 8.0 10.0 1083 12 <0.25 A1 22nd Dec '09 30 13.4 10.0 1192 30 <0.25 A1 28th Dec '09 37 8.0 11.0 1589 27 <0.25 A1 29th Dec '09 38 8.0 11.5 1175 10 <0.25 A1 4th Jan '10 53 8.0 10.0 1092 24 <0.25 A1 5th Jan '10 41 8.0 12.4 1263 11 <0.25 A1 11th Jan '10 49 8.2 17.1 1378 10 <0.25 A1 12th Jan '10 41 9.2 15.0 1088 18 <0.25 A1 19th Jan '10 42 8.0 10.0 1082 27 <0.25 A1 20th Jan '10 38 10.0 18.4 1025 10 <0.25 A1 25th Jan '10 44 11.4 18.6 1178 13 <0.25 A1 26th Jan '10 47 8.6 14.2 1083 29 <0.25 A1 2nd Feb '10 45 8.0 15.0 1083 25 <0.25 A1 3rd Feb '10 42 8.0 12.0 1065 10 <0.25 A1 8th Feb '10 32 8.0 14.6 1164 11 <0.25 A1 9th Feb '10 37 8.0 16.3 1286 11 <0.25 A1 15th Feb '10 43 13.5 15.6 1163 10 <0.25 A1 16th Feb '10 51 9.1 10.8 1085 10 <0.25 A1 22nd Feb '10 47 8.0 10.0 1292 19 <0.25 A1 23rd Feb '10 52 8.0 10.1 1185 10 <0.25 A1 4th Mar '10 53 8.0 18.0 1392 15 <0.25 A1 5th Mar '10 48 8.0 10.0 1282 17 <0.25 A1 12th Mar '10 53 15.0 11.4 1735 14 <0.25 A1 13th Mar '10 49 8.2 14.2 1173 21 <0.25 A2 21st Dec '09 49 8.4 12.6 1252 20 <0.25 A2 22nd Dec '09 47 8.0 12.0 1978 13 <0.25 A2 28th Dec '09 38 12.4 10.0 1973 21 <0.25





(24hr) THC



Sensitive 75 30 30 A2 29th Dec '09 57 11.8 10.5 1581 10 <0.25 A2 4th Jan '10 45 8.0 12.7 1667 17 <0.25 A2 5th Jan '10 35 8.0 19.1 1928 20 <0.25 A2 11th Jan '10 41 8.0 15.1 2196 43 <0.25 A2 12th Jan '10 35 10.8 18.5 1145 16 <0.25 A2 19th Jan '10 49 15.5 10.0 1266 23 <0.25 A2 20th Jan '10 43 8.0 12.3 1542 21 <0.25 A2 25th Jan '10 38 11.7 14.0 1328 11 <0.25 A2 26th Jan '10 41 15.7 11.7 1945 13 <0.25 A2 2nd Feb '10 47 18.8 13.4 1083 13 <0.25 A2 3rd Feb '10 45 14.7 12.5 1292 27 <0.25 A2 8th Feb '10 56 12.4 11.0 1548 16 <0.25 A2 9th Feb '10 42 8.4 10.0 1392 21 <0.25 A2 15th Feb '10 51 10.0 13.7 1287 35 <0.25 A2 16th Feb '10 57 17.5 10.0 1521 14 <0.25 A2 22nd Feb '10 53 8.4 12.6 1092 18 <0.25 A2 23rd Feb '10 48 14.7 22.3 1646 15 <0.25 A2 4th Mar '10 63 9.3 10.0 1378 16 <0.25 A2 5th Mar '10 41 8.0 11.2 1198 36 <0.25 A2 12th Mar '10 52 13.1 10.0 1723 28 <0.25 A2 13th Mar '10 58 10.8 12.5 1548 15 <0.25 A3 23rd Dec '09 54 15.9 17.7 1992 21 <0.25 A3 24th Dec '09 41 12.6 14.8 1535 17 <0.25 A3 30th Dec '10 37 12.7 19.8 1672 20 <0.25 A3 31st Dec '10 48 8.8 23.0 1565 18 <0.25 A3 6th Jan '10 41 14.1 11.4 1362 15 <0.25 A3 7th Jan '10 45 9.1 16.5 2035 33 <0.25 A3 16th Jan '10 61 12.2 22.7 1795 38 <0.25 A3 17th Jan 10 52 11.1 16.6 1536 21 <0.25





(24hr) THC



Sensitive 75 30 30 A3 21st Jan '10 56 13.1 17.6 1398 29 <0.25 A3 22nd Jan 10 49 12.0 15.2 1982 22 <0.25 A3 27th Jan '10 43 13.4 10.3 1581 15 <0.25 A3 28th Jan '10 41 10.5 18.6 1994 18 <0.25 A3 4th Feb '10 55 8.0 10.8 1476 23 <0.25 A3 5th Feb '10 68 11.4 10.0 1635 42 <0.25 A3 10th Feb '10 81 16.1 11.1 1365 17 <0.25 A3 11th Feb '10 59 8.0 22.9 1726 26 <0.25 A3 17th Feb '10 48 12.2 18.8 1282 15 <0.25 A3 18th Feb '10 55 8.0 11.4 1395 28 <0.25 A3 24th Feb '10 47 8.2 16.2 1728 20 <0.25 A3 25th Feb '10 43 11.8 24.5 2163 24 <0.25 A3 8th Mar '10 53 8.0 20.9 2572 33 <0.25 A3 9th Mar '10 62 8.7 12.0 1798 18 <0.25 A3 15th Mar '10 44 10.3 13.7 1540 15 <0.25 A3 16th Mar '10 59 11.4 11.2 1727 17 <0.25 A4 25th Dec '09 53 10.7 10.0 1083 17 <0.25 A4 26th Dec '09 48 9.5 10.0 992 10 <0.25 A4 1st Jan '10 41 12.4 11.4 978 10 <0.25 A4 2nd Jan '10 32 9.9 14.5 981 10 <0.25 A4 8th Jan '10 45 10.8 10.0 887 10 <0.25 A4 9th Jan '10 59 8.0 10.0 942 10 <0.25 A4 23rd Jan '10 54 10.8 18.5 927 10 <0.25 A4 24th Jan '10 51 12.2 10.0 1098 10 <0.25 A4 29th Jan '10 39 14.4 13.5 987 10 <0.25 A4 30th Jan '10 32 16.6 13.6 978 10 <0.25 A4 6th Feb '10 41 21.0 10.0 983 10 <0.25 A4 7th Feb '10 39 8.0 10.0 1076 18 <0.25 A4 12th Feb '10 45 8.0 16.1 1055 13 <0.25





(24hr) THC



Sensitive 75 30 30 A4 13th Feb '10 41 8.0 10.5 1035 10 <0.25 A4 19th Feb '10 35 8.0 10.0 1054 10 <0.25 A4 20th Feb '10 47 8.0 10.0 1118 16 <0.25 A4 26th Feb '10 49 8.0 10.0 1236 21 <0.25 A4 27th Feb '10 53 8.0 12.4 1185 10 <0.25 A4 10th Mar '10 40 10.2 13.4 1245 10 <0.25 A4 11th Mar '10 57 8.0 10.0 1085 14 <0.25 A4 17th Mar '10 45 8.0 10.4 1295 10 <0.25 A4 18th Mar '10 39 8.5 11.2 1084 10 <0.25 A4 23rd Mar '10 43 9.5 10.0 1045 10 <0.25 A4 24th Mar '10 52 12.4 10.5 978 10 <0.25 A5 21st Dec '09 43 16.2 10.0 1075 10 <0.25 A5 22nd Dec '09 45 8.0 10.0 1288 17 <0.25 A5 28th Dec '09 57 9.6 13.8 1522 10 <0.25 A5 29th Dec '09 52 12.7 10.0 1083 10 <0.25 A5 4th Jan '10 40 13.7 14.1 1163 12 <0.25 A5 5th Jan '10 45 9.0 11.1 978 10 <0.25 A5 11th Jan '10 56 8.0 10.0 1083 10 <0.25 A5 12th Jan '10 48 13.8 10.0 1430 13 <0.25 A5 19th Jan '10 43 8.0 10.0 1063 10 <0.25 A5 20th Jan '10 51 8.0 10.0 1245 10 <0.25 A5 25th Jan '10 45 8.0 11.3 1064 10 <0.25 A5 26th Jan '10 39 8.1 16.6 998 10 <0.25 A5 2nd Feb '10 41 9.3 11.7 1545 15 <0.25 A5 3rd Feb '10 55 10.8 10.0 1592 17 <0.25 A5 8th Feb '10 52 14.7 10.8 1344 10 <0.25 A5 9th Feb '10 57 9.2 14.3 1177 10 <0.25 A5 15th Feb '10 52 8.0 12.7 983 10 <0.25 A5 16th Feb '10 48 8.0 10.0 1096 10 <0.25





(24hr) THC



Sensitive 75 30 30 A5 22nd Feb '10 41 8.0 15.2 1045 10 <0.25 A5 23rd Feb '10 35 9.0 12.8 998 10 <0.25 A5 4th Mar '10 42 9.5 10.0 1047 10 <0.25 A5 5th Mar '10 40 8.0 10.0 981 10 <0.25 A5 12th Mar '10 48 12.1 10.0 1062 11 <0.25 A5 13th Mar '10 53 8.0 17.0 1254 15 <0.25 A6 23rd Dec '09 33 8.0 10.0 1092 10 <0.25 A6 24th Dec '09 45 8.0 11.4 1019 13 <0.25 A6 30th Dec '10 37 8.0 10.0 1031 10 <0.25 A6 31st Dec '10 32 9.8 10.0 1019 10 <0.25 A6 6th Jan '10 35 8.0 10.0 1022 10 <0.25 A6 7th Jan '10 35 8.0 12.5 1067 10 <0.25 A6 16th Jan '10 39 11.1 10.0 1073 10 <0.25 A6 17th Jan 10 41 8.0 14.3 1116 13 <0.25 A6 21st Jan '10 33 9.2 10.0 992 10 <0.25 A6 22nd Jan 10 38 8.0 11.6 968 10 <0.25 A6 27th Jan '10 32 8.8 10.0 1022 10 <0.25 A6 28th Jan '10 37 8.6 10.0 1026 10 <0.25 A6 4th Feb '10 41 8.0 10.0 1031 11 <0.25 A6 5th Feb '10 43 8.0 10.0 1072 13 <0.25 A6 10th Feb '10 35 8.0 10.0 988 10 <0.25 A6 11th Feb '10 31 8.0 12.4 1031 10 <0.25 A6 17th Feb '10 31 8.0 10.0 1135 19 <0.25 A6 18th Feb '10 37 8.0 10.0 1112 23 <0.25 A6 24th Feb '10 35 8.0 10.0 1128 10 <0.25 A6 25th Feb '10 41 8.0 10.0 1158 15 <0.25 A6 8th Mar '10 38 8.0 12.3 983 10 <0.25 A6 9th Mar '10 33 8.1 14.7 1008 10 <0.25 A6 15th Mar '10 35 8.0 11.6 1026 21 <0.25





(24hr) THC



Sensitive 75 30 30 A6 16th Mar '10 37 8.0 10.0 1047 10 <0.25 A7 23rd Dec '09 43 9.8 10.1 1064 10 <0.25 A7 24th Dec '09 41 12.1 10.2 1024 10 <0.25 A7 30th Dec '10 38 8.0 10.0 1024 13 <0.25 A7 31st Dec '10 62 13.3 10.0 1063 10 <0.25 A7 6th Jan '10 45 8.0 11.0 1059 10 <0.25 A7 7th Jan '10 58 8.0 12.1 1079 17 <0.25 A7 16th Jan '10 53 8.0 11.6 1084 10 <0.25 A7 17th Jan 10 46 8.0 11.5 1131 26 <0.25 A7 21st Jan '10 42 9.7 11.1 1063 15 <0.25 A7 22nd Jan 10 47 8.0 10.0 1108 10 <0.25 A7 27th Jan '10 59 9.6 12.4 1024 15 <0.25 A7 28th Jan '10 53 8.0 10.0 984 10 <0.25 A7 4th Feb '10 52 8.0 11.6 987 10 <0.25 A7 5th Feb '10 42 8.0 13.6 1109 10 <0.25 A7 10th Feb '10 39 10.3 10.1 1065 15 <0.25 A7 11th Feb '10 46 8.0 12.5 1109 17 <0.25 A7 17th Feb '10 43 8.0 11.8 1022 10 <0.25 A7 18th Feb '10 36 8.0 11.0 1105 10 <0.25 A7 24th Feb '10 50 8.0 10.5 1054 10 <0.25 A7 25th Feb '10 48 8.0 10.0 1024 11 <0.25 A7 8th Mar '10 43 8.0 10.0 1054 10 <0.25 A7 9th Mar '10 41 8.0 12.2 1109 25 <0.25 A7 15th Mar '10 54 8.0 10.3 993 10 <0.25 A7 16th Mar '10 47 8.0 13.1 1031 10 <0.25 A8 25th Dec '09 42 11.5 10.4 1140 18 <0.25 A8 26th Dec '09 48 11.3 11.1 1233 23 <0.25 A8 1st Jan '10 46 15.3 23.3 1287 17 <0.25 A8 2nd Jan '10 50 14.4 21.0 1135 15 <0.25





(24hr) THC



Sensitive 75 30 30 A8 8th Jan '10 40 14.3 18.1 1063 10 <0.25 A8 9th Jan '10 51 15.3 10.9 1084 10 <0.25 A8 23rd Jan '10 44 16.0 10.9 1062 13 <0.25 A8 24th Jan '10 43 10.8 14.0 1191 17 <0.25 A8 29th Jan '10 44 10.0 17.7 1268 19 <0.25 A8 30th Jan '10 49 9.1 14.3 1022 10 <0.25 A8 6th Feb '10 42 13.9 15.0 1349 28 <0.25 A8 7th Feb '10 53 10.3 15.7 1471 33 <0.25 A8 12th Feb '10 42 14.9 16.0 1105 17 <0.25 A8 13th Feb '10 40 11.4 20.3 1022 10 <0.25 A8 19th Feb '10 45 15.6 14.8 1011 10 <0.25 A8 20th Feb '10 42 10.7 11.0 1067 10 <0.25 A8 26th Feb '10 47 13.1 10.0 1198 13 <0.25 A8 27th Feb '10 42 10.9 12.7 1433 18 <0.25 A8 10th Mar '10 38 16.4 11.7 1259 12 <0.25 A8 11th Mar '10 44 16.6 13.2 1105 10 <0.25 A8 17th Mar '10 47 8.1 10.0 1777 21 <0.25 A8 18th Mar '10 53 11.5 18.0 1516 25 <0.25 A8 23rd Mar '10 50 9.8 10.0 1447 17 <0.25 A8 24th Mar '10 42 10.2 14.9 1467 14 <0.25 A9 21st Dec '09 43 8.0 10.0 1052 10 <0.25 A9 22nd Dec '09 41 8.0 10.0 1016 10 <0.25 A9 28th Dec '09 37 8.0 10.0 1072 10 <0.25 A9 29th Dec '09 56 8.0 10.0 1152 10 <0.25 A9 4th Jan '10 32 12.6 10.0 1013 10 <0.25 A9 5th Jan '10 38 9.9 19.7 986 10 <0.25 A9 11th Jan '10 46 8.0 10.0 1113 10 <0.25 A9 12th Jan '10 41 8.0 10.0 1006 13 <0.25 A9 19th Jan '10 49 8.0 10.0 1120 15 <0.25





(24hr) THC



Sensitive 75 30 30 A9 20th Jan '10 50 8.0 10.0 1043 10 <0.25 A9 25th Jan '10 48 8.0 11.4 1109 18 <0.25 A9 26th Jan '10 63 9.2 10.0 1168 10 <0.25 A9 2nd Feb '10 42 9.2 10.0 1011 10 <0.25 A9 3rd Feb '10 48 11.2 10.0 1108 11 <0.25 A9 8th Feb '10 49 8.0 12.8 1003 10 <0.25 A9 9th Feb '10 39 8.0 13.5 982 10 <0.25 A9 15th Feb '10 47 10.5 16.6 1022 10 <0.25 A9 16th Feb '10 45 8.0 12.3 987 10 <0.25 A9 22nd Feb '10 35 8.0 13.7 1005 10 <0.25 A9 23rd Feb '10 49 8.3 12.7 1077 10 <0.25 A9 4th Mar '10 52 8.0 10.0 1045 10 <0.25 A9 5th Mar '10 41 8.2 10.8 1012 10 <0.25 A9 12th Mar '10 37 9.4 11.4 996 10 <0.25 A9 13th Mar '10 39 8.0 10.0 1053 10 <0.25 A10 25th Dec '09 35 8.0 10.0 992 10 <0.25 A10 26th Dec '09 43 8.0 10.0 1011 10 <0.25 A10 1st Jan '10 52 8.0 10.0 996 10 <0.25 A10 2nd Jan '10 41 8.0 10.0 1032 10 <0.25 A10 8th Jan '10 34 8.0 10.0 1020 10 <0.25 A10 9th Jan '10 38 8.0 15.6 984 10 <0.25 A10 23rd Jan '10 48 8.0 10.0 978 10 <0.25 A10 24th Jan '10 30 8.0 10.0 1065 10 <0.25 A10 29th Jan '10 43 9.7 10.0 1105 10 <0.25 A10 30th Jan '10 39 10.9 10.7 1122 10 <0.25 A10 6th Feb '10 47 8.0 10.0 1055 10 <0.25 A10 7th Feb '10 45 8.0 10.0 1041 10 <0.25 A10 12th Feb '10 41 9.1 10.0 1018 10 <0.25 A10 13th Feb '10 39 10.5 10.0 1067 13 <0.25





(24hr) THC



Sensitive 75 30 30 A10 19th Feb '10 39 8.0 10.0 1010 10 <0.25 A10 20th Feb '10 46 8.0 10.4 977 10 <0.25 A10 26th Feb '10 42 8.0 12.5 984 10 <0.25 A10 27th Feb '10 36 8.0 10.0 991 10 <0.25 A10 10th Mar '10 39 8.0 10.6 987 10 <0.25 A10 11th Mar '10 33 9.5 10.5 1039 10 <0.25 A10 17th Mar '10 37 8.0 10.0 1011 10 <0.25 A10 18th Mar '10 41 8.0 10.4 1104 10 <0.25 A10 23rd Mar '10 35 8.0 10.9 1013 10 <0.25 A10 24th Mar '10 38 11.6 10.0 1158 11 <0.25



Annexure 4: Photo Documentation

Adjacent to Site near Dabhasa

Ground water location at Sadhi Village

Surface water location at Sadhi Village Pond

Ground water location at Umraya Village



AAQM at Ekalbara Village

AAQM at Umaraya Village

Mahisagar near Ekalbara Village

Surface water location at Ranu Village Pond



Surface water location at Luna Village Pond

AAQM at Sadhi Village



Annexure 5: Dispersion Modeling Results

Impact on Air Environment

Ambient air monitoring carried out in winter season of year 2009-2010 shows that the ambient air quality for SPM, SO2, NOx, CO are within the limits specified by CPCB.

Table 1: 24 hr average Incremental Increase in GLC Proposed

S. No.

Name of Village/ Industry

(Distance in km / Direction)

Pollutant

Average Monitored Baseline

Concentration (µg/m3)

Total Incremental

GLC (µg/m3)

Total Predictive GLC for

proposed project (µg/m3)

1. Site

SOx 9.1 0.45 9.55 NOx 13.2 0.20 13.4 PM 44 0.18 44.18

2. Dabhasa Village (0.15/SE)

SOx 11.3 1.44 12.74 NOx 12.8 0.64 13.44 PM 47 0.63 47.63

3. Padra Town (4.37/ESE)

SOx 11.2 0.02 11.22 NOx 16.1 0.01 16.11 PM 52 0.01 52.01

4. Mahuvad Village (2.83/WSW)

SOx 10.4 0.45 10.85 NOx 11.5 0.20 11.7 PM 45 0.21 45.21

5. Luna Village (1.95/NE)

SOx 9.9 0.04 9.94 NOx 11.7 0.02 11.72 PM 47 0.02 47.02

6. Ranu Village (3.98 /SSW)

SOx 8.7 0.53 9.23 NOx 11.1 0.24 11.34 PM 47 0.25 47.25

7. Navapura Village (3.09/SW)

SOx 12.6 0.34 12.94 NOx 14.4 0.15 14.55 PM 45 0.16 45.16

8. Umraya Village (2.35/NW)

SOx 8.7 0.00 8.7 NOx 11.4 0.01 11.41 PM 44 0.01 44.01

9. Ekalbara Village (3.05/WNW)

SOx 8.6 0.06 8.66 NOx 10.5 0.03 10.53 PM 40 0.03 40.03

Thus it can be concluded that the impact on ambient air quality due to proposed activities will be within acceptable norms.



Table 2: Incremental Increase in GLC of SOx (µg/m3) to Total Ambient Air SOx Concentration

DIRECTION DISTANCE (Meters) (DEGREES) 75 150 300 450 600 750 825 900 975 1050 1200 1350 1650 2100 2700 3300 4200

360 0.01 0.04 0.03 0.02 0.02 0.02 0.02 0.02 0.02 0.02 0.01 0.01 0.01 0.01 0.01 0.00 0.00 10 0.01 0.04 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 0.00 0.00 0.00

20 0.02 0.06 0.03 0.02 0.02 0.02 0.02 0.02 0.02 0.02 0.01 0.01 0.01 0.01 0.01 0.00 0.00 30 0.04 0.10 0.05 0.03 0.02 0.02 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 40 0.07 0.16 0.09 0.10 0.10 0.10 0.09 0.09 0.08 0.08 0.07 0.06 0.05 0.04 0.03 0.02 0.01

50 0.08 0.20 0.12 0.11 0.11 0.10 0.10 0.09 0.09 0.08 0.07 0.06 0.05 0.04 0.03 0.02 0.01 60 0.07 0.22 0.11 0.08 0.06 0.05 0.05 0.04 0.04 0.04 0.03 0.03 0.02 0.01 0.01 0.01 0.00 70 0.06 0.21 0.12 0.10 0.09 0.08 0.07 0.07 0.06 0.06 0.05 0.05 0.04 0.03 0.02 0.02 0.01

80 0.04 0.18 0.10 0.06 0.04 0.03 0.03 0.03 0.02 0.02 0.02 0.01 0.01 0.01 0.00 0.00 0.00 90 0.04 0.17 0.11 0.09 0.09 0.08 0.07 0.07 0.07 0.06 0.06 0.05 0.04 0.03 0.02 0.02 0.01

100 0.03 0.19 0.12 0.07 0.05 0.04 0.03 0.03 0.03 0.02 0.02 0.02 0.01 0.01 0.00 0.00 0.00

110 0.05 0.28 0.20 0.15 0.13 0.11 0.10 0.10 0.09 0.08 0.07 0.07 0.05 0.04 0.03 0.02 0.02 120 0.08 0.45 0.29 0.17 0.12 0.09 0.08 0.07 0.06 0.06 0.05 0.04 0.03 0.02 0.02 0.01 0.01 130 0.12 0.71 0.49 0.37 0.32 0.28 0.26 0.24 0.23 0.21 0.19 0.16 0.13 0.10 0.07 0.05 0.03 140 0.18 1.03 0.69 0.47 0.38 0.32 0.29 0.27 0.25 0.23 0.20 0.18 0.14 0.10 0.07 0.05 0.04 150 0.24 1.44 0.93 0.58 0.43 0.34 0.31 0.28 0.25 0.23 0.20 0.17 0.13 0.09 0.06 0.05 0.03 160 0.35 1.97 1.28 0.86 0.69 0.58 0.54 0.50 0.47 0.44 0.39 0.34 0.28 0.21 0.15 0.12 0.09 170 0.52 2.79 1.70 0.94 0.61 0.43 0.38 0.33 0.30 0.27 0.22 0.19 0.14 0.10 0.07 0.05 0.03 180 0.80 4.03 2.48 1.55 1.18 0.96 0.88 0.82 0.76 0.71 0.62 0.55 0.45 0.34 0.25 0.20 0.15 190 1.18 5.48 3.23 1.84 1.25 0.92 0.81 0.72 0.65 0.58 0.48 0.41 0.30 0.21 0.14 0.10 0.07

200 1.58 6.90 4.45 3.66 3.44 3.17 3.01 2.86 2.70 2.56 2.28 2.05 1.67 1.27 0.94 0.73 0.53 210 1.90 7.81 4.62 2.99 2.31 1.89 1.72 1.57 1.44 1.33 1.13 0.97 0.73 0.51 0.34 0.24 0.16 220 1.99 7.95 4.74 3.16 2.54 2.13 1.97 1.82 1.69 1.57 1.36 1.19 0.93 0.68 0.48 0.36 0.25

230 1.81 7.20 4.33 2.95 2.41 2.04 1.89 1.75 1.62 1.51 1.31 1.15 0.90 0.66 0.46 0.34 0.24 240 1.45 5.92 3.45 2.10 1.54 1.21 1.09 0.99 0.90 0.82 0.70 0.60 0.45 0.31 0.21 0.15 0.10 250 1.06 4.64 2.89 2.12 1.85 1.65 1.55 1.45 1.37 1.28 1.14 1.01 0.82 0.62 0.45 0.35 0.25

260 0.80 3.56 2.13 1.26 0.89 0.68 0.60 0.54 0.48 0.43 0.36 0.30 0.22 0.15 0.10 0.07 0.05




270 0.62 2.76 1.84 1.51 1.41 1.30 1.23 1.17 1.10 1.04 0.93 0.84 0.69 0.53 0.39 0.31 0.23 280 0.43 1.90 1.17 0.73 0.54 0.43 0.38 0.35 0.31 0.28 0.24 0.20 0.15 0.10 0.06 0.05 0.03

290 0.26 1.14 0.70 0.46 0.36 0.30 0.28 0.26 0.24 0.23 0.20 0.17 0.14 0.11 0.08 0.06 0.04 300 0.13 0.61 0.38 0.24 0.18 0.14 0.13 0.12 0.11 0.10 0.08 0.07 0.05 0.04 0.03 0.02 0.01 310 0.06 0.30 0.18 0.11 0.08 0.07 0.06 0.06 0.05 0.05 0.04 0.04 0.03 0.02 0.01 0.01 0.01

320 0.03 0.15 0.10 0.07 0.06 0.05 0.04 0.04 0.04 0.04 0.03 0.03 0.02 0.02 0.01 0.01 0.01 330 0.01 0.08 0.05 0.03 0.02 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 340 0.01 0.06 0.04 0.03 0.02 0.02 0.02 0.02 0.02 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00

350 0.01 0.05 0.03 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 0.00 0.00 0.00



Table 3: Incremental Increase in GLC of NOx (µg/m3) to Total Ambient Air NOx Concentration


360 0.004 0.019 0.012 0.010 0.010 0.009 0.008 0.008 0.007 0.007 0.006 0.006 0.005 0.003 0.003 0.002 0.002 10 0.004 0.019 0.011 0.006 0.005 0.004 0.003 0.003 0.002 0.002 0.002 0.002 0.001 0.001 0.000 0.000 0.000

20 0.008 0.027 0.015 0.011 0.010 0.008 0.008 0.008 0.007 0.007 0.006 0.005 0.004 0.003 0.002 0.002 0.001 30 0.019 0.046 0.022 0.013 0.010 0.008 0.007 0.006 0.006 0.005 0.004 0.004 0.003 0.002 0.001 0.001 0.001 40 0.031 0.071 0.042 0.044 0.046 0.044 0.042 0.040 0.038 0.035 0.031 0.028 0.022 0.016 0.011 0.008 0.006

50 0.037 0.090 0.051 0.049 0.049 0.045 0.043 0.041 0.039 0.036 0.032 0.029 0.023 0.017 0.012 0.009 0.006 60 0.034 0.096 0.051 0.034 0.027 0.022 0.020 0.018 0.017 0.016 0.013 0.011 0.009 0.006 0.004 0.003 0.002 70 0.026 0.092 0.054 0.042 0.038 0.034 0.032 0.030 0.029 0.027 0.024 0.021 0.017 0.013 0.010 0.007 0.005 80 0.020 0.081 0.046 0.028 0.020 0.015 0.013 0.012 0.011 0.010 0.008 0.007 0.005 0.003 0.002 0.001 0.001 90 0.016 0.074 0.049 0.041 0.038 0.035 0.033 0.031 0.029 0.028 0.025 0.022 0.018 0.014 0.010 0.008 0.006

100 0.015 0.083 0.053 0.032 0.023 0.017 0.015 0.013 0.012 0.011 0.009 0.007 0.005 0.003 0.002 0.001 0.001 110 0.021 0.124 0.086 0.065 0.056 0.049 0.045 0.042 0.040 0.037 0.033 0.029 0.024 0.018 0.013 0.010 0.007 120 0.035 0.202 0.130 0.077 0.053 0.040 0.035 0.031 0.028 0.026 0.022 0.019 0.014 0.010 0.007 0.005 0.003 130 0.056 0.318 0.219 0.165 0.142 0.123 0.114 0.107 0.100 0.093 0.082 0.072 0.057 0.042 0.030 0.022 0.015 140 0.081 0.460 0.305 0.209 0.167 0.139 0.128 0.119 0.110 0.102 0.089 0.079 0.062 0.046 0.032 0.024 0.017 150 0.112 0.641 0.412 0.258 0.190 0.150 0.135 0.123 0.112 0.103 0.088 0.076 0.058 0.041 0.028 0.020 0.013 160 0.160 0.880 0.568 0.382 0.307 0.258 0.239 0.222 0.207 0.194 0.171 0.152 0.122 0.092 0.068 0.052 0.038

170 0.236 1.242 0.753 0.414 0.268 0.192 0.167 0.147 0.131 0.118 0.098 0.083 0.062 0.043 0.030 0.022 0.015 180 0.366 1.795 1.096 0.685 0.520 0.426 0.391 0.361 0.335 0.313 0.275 0.244 0.197 0.151 0.112 0.088 0.066 190 0.539 2.442 1.429 0.814 0.551 0.408 0.358 0.318 0.285 0.257 0.213 0.179 0.133 0.091 0.062 0.046 0.032

200 0.719 3.075 1.971 1.622 1.524 1.402 1.333 1.264 1.195 1.130 1.009 0.904 0.736 0.561 0.415 0.322 0.235 210 0.862 3.478 2.044 1.320 1.024 0.835 0.761 0.695 0.637 0.585 0.498 0.428 0.324 0.226 0.151 0.108 0.070 220 0.903 3.540 2.097 1.399 1.123 0.943 0.870 0.804 0.745 0.692 0.601 0.526 0.412 0.301 0.212 0.158 0.108

230 0.822 3.204 1.913 1.305 1.065 0.903 0.835 0.773 0.718 0.667 0.580 0.508 0.398 0.290 0.204 0.152 0.104 240 0.657 2.634 1.525 0.926 0.680 0.536 0.483 0.437 0.398 0.364 0.307 0.263 0.198 0.138 0.093 0.067 0.044 250 0.481 2.064 1.277 0.939 0.821 0.728 0.684 0.643 0.604 0.568 0.503 0.448 0.361 0.273 0.200 0.154 0.111




260 0.363 1.584 0.940 0.558 0.394 0.300 0.265 0.236 0.212 0.191 0.158 0.132 0.097 0.065 0.043 0.030 0.020 270 0.281 1.230 0.815 0.669 0.625 0.574 0.545 0.516 0.488 0.461 0.412 0.370 0.302 0.232 0.174 0.136 0.101

280 0.195 0.847 0.515 0.322 0.239 0.189 0.169 0.152 0.138 0.125 0.104 0.088 0.065 0.044 0.028 0.020 0.013 290 0.116 0.509 0.309 0.202 0.160 0.134 0.124 0.115 0.107 0.099 0.087 0.077 0.062 0.047 0.034 0.027 0.019 300 0.057 0.271 0.166 0.104 0.079 0.063 0.057 0.052 0.047 0.044 0.037 0.032 0.024 0.017 0.011 0.008 0.005

310 0.027 0.132 0.080 0.049 0.036 0.029 0.027 0.024 0.022 0.021 0.018 0.016 0.012 0.009 0.006 0.005 0.003 320 0.012 0.068 0.044 0.030 0.025 0.021 0.020 0.018 0.017 0.016 0.014 0.012 0.010 0.007 0.005 0.004 0.002 330 0.006 0.036 0.024 0.014 0.010 0.007 0.006 0.006 0.005 0.004 0.004 0.003 0.002 0.002 0.001 0.001 0.000

340 0.004 0.025 0.017 0.012 0.010 0.008 0.008 0.007 0.007 0.006 0.005 0.005 0.004 0.003 0.002 0.002 0.001 350 0.004 0.021 0.013 0.008 0.005 0.004 0.003 0.003 0.003 0.002 0.002 0.002 0.001 0.001 0.001 0.000 0.000



Table 4: Incremental Increase in GLC of PM (µg/m3) to Total Ambient Air PM Concentration


360 0.00 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 0.00

10 0.00 0.02 0.01 0.01 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 20 0.01 0.03 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 0.00 30 0.02 0.05 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 0.00 0.00 0.00

40 0.03 0.07 0.04 0.04 0.05 0.04 0.04 0.04 0.04 0.04 0.03 0.03 0.02 0.02 0.01 0.01 0.01 50 0.04 0.09 0.05 0.05 0.05 0.05 0.04 0.04 0.04 0.04 0.03 0.03 0.02 0.02 0.01 0.01 0.01 60 0.03 0.10 0.05 0.03 0.03 0.02 0.02 0.02 0.02 0.02 0.01 0.01 0.01 0.01 0.00 0.00 0.00

70 0.02 0.09 0.06 0.04 0.04 0.04 0.03 0.03 0.03 0.03 0.02 0.02 0.02 0.01 0.01 0.01 0.01 80 0.02 0.08 0.05 0.03 0.02 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 0.00 90 0.01 0.07 0.05 0.04 0.04 0.04 0.03 0.03 0.03 0.03 0.03 0.02 0.02 0.01 0.01 0.01 0.01

100 0.01 0.08 0.05 0.03 0.02 0.02 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 110 0.02 0.12 0.09 0.07 0.06 0.05 0.05 0.04 0.04 0.04 0.03 0.03 0.02 0.02 0.01 0.01 0.01 120 0.03 0.20 0.13 0.08 0.06 0.04 0.04 0.03 0.03 0.03 0.02 0.02 0.01 0.01 0.01 0.01 0.00 130 0.05 0.31 0.23 0.17 0.15 0.13 0.12 0.11 0.10 0.10 0.09 0.08 0.06 0.04 0.03 0.02 0.02 140 0.07 0.46 0.31 0.22 0.17 0.14 0.13 0.12 0.11 0.11 0.09 0.08 0.06 0.05 0.03 0.03 0.02 150 0.10 0.63 0.43 0.27 0.20 0.16 0.14 0.13 0.12 0.11 0.09 0.08 0.06 0.04 0.03 0.02 0.01 160 0.14 0.87 0.59 0.39 0.32 0.27 0.25 0.23 0.21 0.20 0.18 0.16 0.13 0.10 0.07 0.05 0.04 170 0.21 1.23 0.78 0.43 0.28 0.20 0.17 0.15 0.14 0.12 0.10 0.09 0.07 0.05 0.03 0.02 0.02 180 0.33 1.79 1.13 0.71 0.54 0.44 0.41 0.37 0.35 0.33 0.29 0.25 0.21 0.16 0.12 0.09 0.07

190 0.49 2.44 1.48 0.85 0.57 0.42 0.37 0.33 0.30 0.27 0.22 0.19 0.14 0.10 0.07 0.05 0.03 200 0.65 3.07 2.03 1.66 1.56 1.44 1.38 1.31 1.24 1.17 1.05 0.94 0.77 0.59 0.43 0.34 0.25 210 0.79 3.48 2.11 1.36 1.06 0.86 0.79 0.72 0.66 0.61 0.52 0.45 0.34 0.24 0.16 0.11 0.07

220 0.83 3.55 2.17 1.44 1.16 0.98 0.90 0.83 0.77 0.72 0.62 0.55 0.43 0.31 0.22 0.16 0.11 230 0.75 3.21 1.98 1.34 1.10 0.93 0.86 0.80 0.74 0.69 0.60 0.53 0.42 0.30 0.21 0.16 0.11 240 0.60 2.64 1.58 0.96 0.70 0.56 0.50 0.45 0.41 0.38 0.32 0.27 0.21 0.14 0.10 0.07 0.05

250 0.44 2.06 1.32 0.96 0.84 0.75 0.71 0.66 0.63 0.59 0.52 0.47 0.38 0.29 0.21 0.16 0.12




260 0.33 1.58 0.97 0.58 0.41 0.31 0.28 0.25 0.22 0.20 0.16 0.14 0.10 0.07 0.04 0.03 0.02 270 0.26 1.23 0.84 0.69 0.64 0.59 0.56 0.53 0.51 0.48 0.43 0.38 0.32 0.24 0.18 0.14 0.11 280 0.18 0.85 0.53 0.33 0.25 0.20 0.18 0.16 0.14 0.13 0.11 0.09 0.07 0.05 0.03 0.02 0.01

290 0.11 0.51 0.32 0.21 0.17 0.14 0.13 0.12 0.11 0.10 0.09 0.08 0.06 0.05 0.04 0.03 0.02 300 0.05 0.27 0.17 0.11 0.08 0.07 0.06 0.05 0.05 0.05 0.04 0.03 0.03 0.02 0.01 0.01 0.01 310 0.02 0.13 0.08 0.05 0.04 0.03 0.03 0.03 0.02 0.02 0.02 0.02 0.01 0.01 0.01 0.00 0.00

320 0.01 0.07 0.05 0.03 0.03 0.02 0.02 0.02 0.02 0.02 0.01 0.01 0.01 0.01 0.01 0.00 0.00 330 0.00 0.04 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 340 0.00 0.02 0.02 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.01 0.00 0.00 0.00 0.00 0.00 0.00

350 0.00 0.02 0.01 0.01 0.01 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00 0.00



Figure 1: Concentration of SOx



Figure 2: Concentration of NOx



Figure 3: Concentration of PM

GLOBEX LABORATORIES (R&D) LTD. MANUFACTURING OF YELLOW PIGMENTS

AND RED PIGMENTS ANNEXURE


Annexure 6: National Ambient Air Quality Standards

S. No.

Pollutant Time Weighted Average

Concentration in Ambient Air

Industrial, Residential, Rural

and Other Area

Ecologically Sensitive Area

(Notified by Central

Government)

Methods of Measurement

(1) (2) (3) (4) (5) (6) 1. Sulphur Dioxide

(SO2), µg/m3 Annual*

24 hours**

50

80

20

80

- Improved West and Gacke Method

- Ultraviolet Fluorescence Method

2. Nitrogen Dioxide (NO2), µg/m3

Annual*

24 hours**

40

80

30

80

- Modified Jacob & Hochheiser (Na-arsenite) Method

- Chemiluminescence Method

3. Particulate Matter (size less than 10 µm) or PM10 µg/m3

Annual*

24 hours**

60

100

60

100

- Gravimetric Method - TOEM - Beta Attenuation

Method 4. Particulate Matter

(size less than 2.5 µm) or PM2.5 µg/m3

Annual*

24 hours**

40

60

40

60

- Gravimetric Method - TOEM - Beta Attenuation

Method 5. Ozone (O3) µg/m3 8 hours**

1 hour**

100

180

100

180

- UV Photometric Method


- Chemical Method 6. Lead (Pb) µg/m3 Annual*

24 hours**

0.50

1.0

0.50

1.0

- AAS/ICP method after sampling on EPM 2000 or equivalent filter paper

- ED-XRF using Teflon filter

7. Carbon Monoxide (CO) µg/m3

8 hours**

1 hour**

02

04

02

04

- Non Dispersive Infra Red (NDIR) spectroscopy

8. Ammonia (NH3) µg/m3

Annual*

24 hours**

100

400

100 400


- Indophenols blue method

9. Benzene (C6H6) µg/m3

Annual* 05 05 - Gas chromatography based continuous analyzer

- Adsorption and Desorption followed by GC analyzer

10. Benzo(a)Pyrene (BaP)-Particulate phase only, µg/m3

Annual* 01 01 - Solvent extraction followed by HPLC/GC analysis

11. Arsenic (As), µg/m3

Annual* 06 06 - AAS/ICP method after sampling on EPM 2000 or equivalent filter paper

12. Nickel (Ni), µg/m3 Annual* 20 20 - AAS/ICP method




S. No.

Pollutant Time Weighted Average

Concentration in Ambient Air

Industrial, Residential, Rural

and Other Area

Ecologically Sensitive Area

(Notified by Central

Government)

Methods of Measurement

(1) (2) (3) (4) (5) (6) after sampling on EPM 2000 or equivalent filter paper

* Annual arithmetic mean of minimum 104 measurements in a year at a particular site taken twice a week 24 hourly at uniform intervals.

** 24 hourly or 08 hourly or 01 hourly monitored values, as applicable, shall be complied with 98% of the time in a year. 2% of the time, they may exceed the limits but not on two consecutive days of monitoring.

Note:

Whenever and wherever monitoring results on two consecutive days of monitoring exceed the limits specified above for the respective category, it shall be considered adequate reason to institute regular

or continuous monitoring and further investigation.



Annexure 7: Long-term Climatological Data






Annexure 8: Certificate of Accreditation issued by the QCI

GLOBEX LABORATORIES (R&D) LTD. MANUFACTURING OF YELLOW PIGMENTS AND RED PIGMENTS

ANNEXURE


Annexure: 9 Emergency Organizations Emergency Organization requires to be entered in the format suggested in Table 1.

Table 1: Emergency Organization

EMERGENCY ORGANISATION CHART

Designation Name Phone (O) Phone (R) Phone (M)

EMERGENCY CONTROL CENTRE (ECC) SITE MAIN CONTROLLER

Project Manager

OTHER KEY PERSONNEL (OKP)

Operations Manager

Safety Officer (in charge of fire control)

INCIDENT CONTROLLERS (IC)

General Shift

Second Shift

Third Shift

Alternate

KEY WORKERS

Communications

Transport & Logistics

Maintenance

Public Relations / Liaison Officer

Pollution Control

KEY PERSONNEL, OFFICE

Chairman

Managing Director

Director

EXTERNAL AGENCIES (DISTRICT LEVEL)

District Collector

Chief Fire Officer

Controller of Explosives

Chief, Civil Defence

SP / DSP (Police)

District Health Officer

Chief Medical Officer

RO, Pollution Control Board


ANNEXURE


EMERGENCY ORGANISATION CHART

Designation Name Phone (O) Phone (R) Phone (M)

District Energy Officer

GEB Office

EXTERNAL AGENCIES (LOCAL LEVEL)

Sub-divisional Magistrate

Inspector of Factories

Fire Officer

Station House Officer (Police)

Block Development Officer

Representative, Civil Defence

Primary Health Officer

Editor, News paper

Village Sarpanch

Doctor, 1

Doctor, 2

Raising of Alarm A siren system may be installed at the site, as per the given in Figure 4. Alternately, guidance on raising an alarm has been covered and the same may be consulted.


ANNEXURE


Figure 4: Method of Raising Alarms

Site Layout Plan with Escape Routes and Assembly Points A layout of the site is to be prepared incorporating escape routes and assembly points. Location of the emergency control center(s) are to be marked on the map.

Emergency Control Centers Location of ECC is to be shown on the site layout map. The items actually made available in the ECC are as mentioned in Table 2.

Table 2: Items to be made available at Emergency Control Centre

Main ECC at -----: Phone: Alternate (If Main is affected): CCR: Phone:

Sr. No.

Communication system and emergency use items

Number/ quantity

Sr. No.

Communication system and

emergency use items

Number/ quantity

1

Communication 1. Intercom sets

2. External phone set0073 3. Telephone directory 4. Company Directory

5. List of Important phone numbers 6. Walkie-talkies 7. Wireless set 8. Mobile phone

9. Portable loud speakers

1 1 1 1 1 1 1 1 1

5 Recording system 1. Tape recorder 2. Camera or video

recorder 3. Cassettes

1 1 2


ANNEXURE


Main ECC at -----: Phone: Alternate (If Main is affected): CCR: Phone:

Sr. No.

Communication system and emergency use items

Number/ quantity

Sr. No.

Communication system and

emergency use items

Number/ quantity

2

Documents 1. Site Plan

2. Layout plan with hazard zones, assembly points marked and location of siren, safety/fire system shown (Display)

3. Stock list of Fire extinguishers 4. Fire-water system and additional

sources of water 5. DMP Flip chart,

6. Copy of First Aid (Appendix-13) 7. Mutual Aid Members,

8. List of employees and addresses and phones,

9. Reference book: Manual of EHS-Management.

1 1 1 1 1 1 1 1

6 Utility items 1. Torches (Flame proof)

with Green and Red signaling switches

2. Umbrellas 3. Rain coats

2 2 2

3 Wall display 1. Site plan

2. Layout plan 3. Emergency Organization.

4. Emergency Phone Numbers.

1 1 1 1

7

PPEs 1. Breathing apparatus

2. Hydrocarbon gas asks (Canister type)

3. Gloves 4. Gum boots

5. Goggles 6. Aprons

1 4

2-Pairs 2-Pairs 2-Pairs

2 4 Stationary

1. Note pads 2. Pens/pencils

3. Erasures

5 5 5

Role of Site Main Controller As soon as he is notified about the incident, the SMC, shall first visit the Incident site, review the

actions and proceed to the Emergency Control Center and take charge of the incident,

The SMC shall have over all responsibility for directing operations and calling outside help from Emergency Control Center,

SMC shall assess the situation quickly and find out the level of Emergency (L1, L2, L3) from the Incident Controller, FOR :

Level 1 - EMERGENCY: May be handled with the resources available within the factory premises.

Level 2 - EMERGENCY: On-Site Emergency plan should be activated

Level 3 - EMERGENCY: Action to be taken to operate the Off-Site Emergency plan with District Authorities.

Ensure that Key-Personnel are called-in,

Direct all Emergency Operations within the approved area with the following priorities:


ANNEXURE


Personnel Safety,

Plant, Property and Environment Safety,

Minimum loss of production.

Continually review & assess possible developments to determine most probable cause of events.

Direct the safe shut down of plants in consultation with the Incident Controller and Key-Personnel if necessary,

Check that all non-essential workers, visitors, contractors are evacuated to assembly points.

Give instructions to the Fire Fighting and rescue team,

If necessary for evacuation of the neighboring population,

Ensure that search for casualties within the affected area have been properly and timely rescued, first aid provided & arrange for hospitalization of victims and additional help if required.

Ensure that P&A In-Charge liaise with out-side agencies such as Police, Services, District Emergency Authorities, Collector and Dy. Director of Factories. Provide advice on possible effects to areas out-side the factory,

Arrange for up-to-date recording of Emergencies.

Do not restart the plant unless it is declared safe to start by competent authority.

Role of Incident Controller Incident Controller’s Primary duty is to take charge of the scene of Incident. His responsibilities / duties are as under:

Ensure on top priority, any victims are rescued as per EER, appropriate first aid provided and shifted to nearest doctor/hospital,

He may be required to take decisions whether to stop or continue any process and take technical decisions to control the incident and simultaneously inform / consult Senior Officer as per requirement.

Immediately assess the scale of emergency likely to exist i.e. L1, L2, or L3 and take action as per the emergency.

The Incident Controller will work under the directions of the Site Main Controller. However, till his arrival he may have to execute the following responsibilities:

Direct for evacuation of plant and other areas likely to be affected by the Emergency.

Ensure Key-Persons are called-in.

Direct all operations within the affected area with the following priorities:

Ensure the safety of personnel.

Minimize damage to Plant, Property and Environment.

Minimize loss of Material.

Other Emergency Services to be managed by the incident controller

1. Direct for search of casualties.

2. Evacuate Non-Essential workers to Assembly Points. 3. Brief the Site Main Controller and keep him informed about the developments.


ANNEXURE


Preserve evidences that will be necessary for subsequent inquiry in to the causes of the emergency and deciding on the preventive measures.

Role of Fire & Safety Services These services are to be provided by the Chief Fire & Safety Officer, Fire Safety Officer and Assistant Fire Safety Officer, whose roles are described.

Roles of Chief Fire and Safety Officer (CFSO) / Fire Safety Officer (FSO), in Order of Priority

1. He shall be the only person to direct the Fire Fighting and other Emergency Operations while other Fire & Safety officers shall assist him.

2. He shall keep in constant touch with Site Main Controller & Incident Controller and Key-Personnel. 3. If required, he is to get the help from: 4. State Fire Brigade located at _______ 5. Fire Station Phone No. is ______ 6. Mobilize Personal Protective Equipments and other Safety Appliances. Will direct crew members of

the scene of Emergency & arrange replenishment of equipments / Extinguishing media etc.

Role of Assistant Fire & Safety Officer (AFSO)

On being notified about the location of fire / gas leak, he is to immediately proceed to the scene of incident with crew.

He will position the Fire Tender at proper place depending upon the wind direction so as to ensure safety of the crew. For gas leak, he will start fogging/fine spray jet, and for HSD fire he will start foam,

Till the arrival of CFSO / FSO, guide the Fire Crew in Fire Fighting and rescue operation by giving clear cut instructions.

Ensure that the crew members are provided with proper Safety Equipments for tackling the Emergency.

Assessing the severity of the Incident, immediately report to Emergency Control Room.

Call for additional requirement such as vehicle, equipments, Extinguishing media or help from outside agencies.

Roles of Fire Crew Members

On hearing Fire Alarm / Emergency Siren, they shall immediately report to the Fire Control Room and proceed to the scene of the Incident and work under the direction of AFSO.

Fire Control Room Operator (Fireman)

1. Immediately inform to CFSO / FSO / AFSO about the incident and work as directed by them. Inform the main security gate.

2. See that pressure in Fire Hydrant System is maintained.

Role of Pollution Control Services – Head (Environment)

After declaration of Major Emergency (i.e. L2 or L3), by the Site Main Controller he will:

He will arrange for announcements to be made to the general public in case of Level-3 Emergency.

He will co-operate with the off site emergency controller i.e. local crisis group authorities, in evacuation and medical assistance programme.


ANNEXURE


He will arrange for the suitable treatment of wastewater and hazardous wastes generated by the emergency control activities

Role of Medical Services - Medical Officer 1. On being intimidated about the emergency, he will immediately contact the Site Main Controller.

2. He will render necessary treatment at the first-aid centre and nearby hospital(s). 3. If required, he will arrange for hospitalization and treatment of patients in outside hospitals. 4. He will mobilize extra medical assistance from outside, if necessary. 5. He will make arrangements for treating affected public (if any) with the help of the Head

(Environment)

Role of other medical staff

As directed by the Medical Officer.

Engineering Services - Maintenance In-Charge On hearing of the emergency siren, he will immediately contact emergency control room and

arrange for engineering services related to mechanical, electrical, instrumentation & automotive equipments such as crane, heavy vehicle, lifting M/C & NDT services as the situation demands.

He will arrange mobile equipment like Crane, Fork Lifts, and others, if required.

He will mobilize more maintenance staff for help if required for emergency engineering work.

Manager (Electrical)

He will mobilize more man-power if required for Emergency Electrical Work.

He will direct concerned personnel for providing extra lighting / isolating electrical supply as per requirements.

Manager / Superintendent (Instrumentation)

He will mobilize more-man power if required for emergency instrumentation work.

Welfare Services - Role of Welfare Officer He will co-ordinate the passing on of information to relatives of affected persons,

He will depute one person each, to all assembly points to carry head count of all personnel, and pass on the information to the Chief Emergency Controller,

He will arrange the presence of company representatives at the hospital(s) to look after the needs of the affected personnel,

He will prepare records of affected personnel noting their local and permanent address,

Arrangement of hot drinks / snacks / food as required will be carried out under his supervision.

Security Services - Role of Security In-Charge (Security Officer / Asst. Security Officer)

On hearing the emergency siren, he shall find out the location of the incident (fire / gas leak / spill / explosion) and inform the location of the same to the key personnel coming to the plant.

He will depute the security guards for manning gates and traffic control at the incident site,

He will prevent unauthorized entry in to the site


ANNEXURE


He will render assistance as demanded by the chief fire & safety officer or the fire & safety officer,

He will mobilize additional security force for help, if required,

He will direct ambulance(s) and emergency vehicle(s) to the scene of incident,

He will help evacuate persons within the scene of incident,

As directed by the site main controller, he may be required to operate the public address (PA) system for warning surrounding villages for evacuation.

Security Guards

On hearing the Emergency Siren, they will contact the security officer and work under his directions.

Replenishment Services - Role of Materials / Store Officer Arrangement of additional manpower for handling store items.

Issuing of items / equipments required during emergency.

Taking immediate action of emergency procurements & arrange additional man-power for local purchases, if required,

Co-ordination with Manager (Finance) for financial requirements.

Role of Mutual-Aid Members – Role of Mutual Aid Scheme Partner

(In case there is a mutual-aid scheme between MPL and surrounding industries in the vicinity).

1. On receiving the call they shall proceed immediately with fire crew & fire tenders,

2. They will be guided to the place of the incident by the main gate security guard, 3. The fire crew in-charge will report to the fire officer of the unit in which the incident has occurred, 4. The heads of the assisting fire brigades deputed by mutual aid scheme partners will ensure safety of

their crew members involved in emergency operations.

Internal Emergency Reporting Procedure and Communication The role of the first eye witness is important. The first eye witness may or may not be competent in facing emergencies, and accordingly, his actions will differ.

Trained first eye witness

If the first eye witness is a suitably trained or competent person, he will carry out the following on witnessing an abnormal incident:

1. Look at the wind sock and note the wind direction. He will then shout (preferably in local language):

“Fire, Fire …..” in case of a fire “Gas Leak, Gas Leak …..” in case of a gas leak 2. Ensuring his own safety, he will control the incident to the extent possible. This could be done by

carrying out first-aid fire fighting. 3. He will then inform the incident controller about the nature of the incident and actions taken so far. 4. With due safety to self and using appropriate PPE’s, if available, he will try to remove any accident

victim from the hazard zone.


ANNEXURE


Untrained first eye witness

If the first eye witness is not a suitably competent or trained person, he shall do the following on observing any abnormal incident:

1. Look at the wind sock and note the wind direction. He will then shout (preferably in the local language):

“Fire, Fire …..” in case of a fire “Gas Leak, Gas Leak …..” in case of a gas leak 2. He will then look for the nearest competent and trained person, about the incident. Alternately, he

will inform the incident controller through available communication channels or in person. 3. On receipt of incident report, the Incident Controller initiates action directly or through his team

members immediately near the incident site, and: To prevent the incident from turning into an emergency, initiates action by closing isolation valves,

and starting of first aid firefighting, or by preventing explosion of gas leak by fogging as appropriate, Calls firemen to take control of incident site, save human life, fight fire and prevent explosions, Directs all key personnel and essential workers to take up their responsibilities, Informs site main controller who on arrival, will declare an emergency.

Safe Assembly Points The safe assembly points for the site are as mentioned in Table 3.

Table 3: Safe Assembly Points for the Site

Assembly Point No. Location

1 Location 1:

2 Location 2:

3 Location 2:

4 Location 4:

Escape, Evacuation & Rescue (EER) Plan Escape

Non-essential personnel have to escape through safe escape route towards the nearest assembly point.

Evacuation

All non-essential personnel who have assembled at the safe assembly points have to be evacuated from the site, then noted down as part of head count and evacuated to temporary shelter outside, like nearest village school, panchayat office or other area as previously determined.

Rescue

On receipt of Incident information, any trapped personnel have to be rescued. This requires rigorous training. The rescuers must first ensure their own safety. There should be at least two rescuers for each victim to be rescued. The following procedure may be followed:

1. Preplan the rescue operation as to who will hold shoulders and who the legs of the victim 2. Ensure appropriate gas mask and other PPE is worn by each rescuer


ANNEXURE


3. See the nearest windsock and approach the site of victim from upwind. If no PPE is available near by, then take a deep breath, hold breath and approach

4. Undertake rescue operation swiftly and confidently 5. Check victims first needs 6. Impart first aid as appropriate, including CPR and oxygen breathing 7. Call for ambulance and shift victim to nearest doctor/hospital.

Maximum Credible Loss Scenarios (MCLS) The results of the consequence analysis leads to the possibility of the MCLS’ results as presented in Table 4.

Table 4: Maximum Credible Loss Scenarios for Organic Coatings Project Site

Sr. No. MCLS Consequence Radial Distance

Damage

The Plant Layout is given overleaf. Thumb Rule for Identifying Stability Class

During any Hazardous gas release, the Atmospheric Stability Class plays a very important role in fatality and injury. Information presented in Table 5 should help any one to guess fairly accurately the Atmospheric Stability Class by looking at the time, and the sky.

Table 5: Thumb Rules for Identifying Stability Class

Sr. No.

Time Sky condition Likely Stability Class

1. Any time of day or night Heavy winds (>5m/s), thick clouds (OKTAS=8)

D

2. Dawn and dusk Clear or cloudy D

3. Sunrise time till 10.00 AM Clear C

4. 10 AM - 2 PM Bright and sunny, low winds (< 2 m/s)

A, A-B or B

5. 10 AM - 2 PM Bright and sunny, moderate winds (2 m/s – 3 m/s)

A-B, B, or C

6. 10 AM - 2 PM Bright and sunny, moderate to heavy winds (3 m/s – 5 m/s)

B, B-C or C

7. 2 pm – 5 pm Clear sky B to C

8. 5 PM – Sunset time Clear sky C

9. Dusk Clear sky D

10. Night Clear sky E-F

11. Night Low wind (< 2 m/s) Unconfirmed (UC)


ANNEXURE


Mutual Aid Organizations Identified mutual aid organizations are covered in Table 6.

Table 6: Identified Mutual Aid Organizations

Sr. No. Mutual Aid Organization Name, Address and Name of Key Person

Phone Nos.

1

2

3

4

Mock Drill & Review Procedure The mock drill and review procedures are as follows:

Every one should synchronize his watch daily with the main clock at security gate to ensure the timings recorded by observers match with each other,

One mock drill is to be conducted once in a period of 6-Months,

The plan of mock drill should be known to Site Main Controller and Incident Controller and observers only,

Mock drill should be against one of the MCLS covered in the Report,

There should be at least two mock victims,

All the steps of DMP from available incident report raised by a trained or untrained observer to the all clear siren are to be rehearsed,

Observers to be set up at the Incident Site, at each Assembly point, ECC and First Aid Center.

Observers should record each activity with timings and head counts etc.,

All clear siren to be sounded only after head count tallies with gate entry list.

After all clear is sounded, all personnel belonging to Emergency Organization should assemble at the pre decided conference room for Mock drill review,

Review to be conducted to check effectiveness of DMP-Implementation in terms of the following:

The first witness’ incident call, Actions by Incident Controller to prevent Incident transforming in to Emergency, and subsequent

steps for Emergency actions, EER operations, Plant shut down, Communication system, Other activities, Review DMP to overcome deficiencies in the Mock Drill.


ANNEXURE


Offsite Plan Components Since there are no other major industrial or project activities in the entire Organic Coatings Project area, the offsite plan for the area is likely to include only Organic Coatings MCLS’ having offsite impacts. Table 7 gives these MCLS having offsite impact.

Table 7: MCLS’ to be considered in Preparation of Offsite Emergency Plan

MCLS Impact Limit MCLS’

Fatality Onsite and Offsite

Injury Onsite and Offsite

Both these MCLS need to be covered under the offsite plan.

Based on the above MCLS and the details of the hazard distances of these, the detailed offsite plan may be drawn up in consultation with the Local Authorities.



Annexure: 10 Analysis Reports of Recently Collected Ground Water Samples from Padra Region

S. No. Parameters Unit

IS 10500 Standard Limits for drinking

water Ground Water Quality

Desirable

limit

Permissible

limit

GW1- Near Village

Pond Dabhasa

GW2- Near Gram Panchayat

Luna

GW3- Near Water

tank Ekalbara

GW4- Near

Temple Umraya

GW5- Near Gram panchayat Mahuvad

GW6- Near Gram panchayat

Luna


Luna

GW8- Nana Ekalbara

Road

Source Hand pump New Borewell Hand pump Hand

pump Hand pump

Old Borewell

Hand pump Hand pump

Date of Sampling 15/4/11 17/4/11 26/4/11 26/4/11 27/4/11 28/4/11 28/4/11 28/4/11

1 pH pH scale 6.5-8.5 6.5-8.5 7.14 7.2 7.11 7.41 7.83 7.79 7.74 7.51

2 Temperature o C NS NS 28 28 28 28 28 28 28 28

3 Turbidity NTU 5 10 30 20.7 21.1 25.3 30.6 20.9 31.3 24.8

4 TDS mg/lit 500 2000 256 480 684 1276 460 352 336 1200

5 Electrical conductivity µmho/cm NS NS 356 686 989 1493 659 523 428 1681

6 COD mg/lit NS NS <4 <4 <4 <4 <4 <4 <4 <4

7 BOD mg/lit NS NS <1 <1 <1 <1 <1 <1 <1 <1

8 Ammonical Nitrogen mg/l NS NS <0.056 <0.056 <0.056 <0.056 <0.056 5.88 <0.056 3.96

9 Phenol mg/lit 0.001 0.002 <0.01 <0.01 <0.01 <0.01 <0.01 <0.01 <0.01 <0.01

10 Chlorides mg/lit 250 1000 65 160 305 525 170 160 100 695

11 Sulphates mg/lit 200 400 2 34 48 10 40 28 12 190

12 SAR - NS NS 0.72 2.1 8.17 14.26 4.06 0.83 1.11 2.28

13 Total Hardness mg/lit 300 600 300 430 230 220 340 530 300 1250

14 Ca++ Hardness mg/lit NS NS 128 232 142 92 154 216 172 772

15 Mg++ Hardness mg/lit NS NS 172 198 88 128 186 314 128 4878

16 Total Alkalinity mg/lit 200 600 350 370 300 380 660 560 510 430

17 Nitrate mg/lit 45 100 3.96 19.49 17.51 43.85 41.79 3.06 Nil 21.39

18 Fluoride mg/lit 1 1.5 0.14 0.28 0.05 0.58 0.38 0.15 0.59 0.21

19 Sodium mg/lit NS NS 28.8 100.5 285.7 405.5 148.5 44.3 44.3 186.2

20 Potassium mg/lit NS NS 4.7 4.9 4.7 24 4.8 5.2 2.4 5.8

21 Calcium mg/lit 75 200 51.3 92.99 56.91 36.87 61.72 86.57 68.94 309.42

22 Magnesium mg/lit 30 100 41.8 48.11 21.38 31.1 45.2 76.3 31.1 116.15

23 Salinity mg/lit NS NS 116.96 287.91 548.83 764.76 215.93 287.91 179.94 1250.61

24 Total Nitrogen mg/lit NS NS 0.91 4.48 4.03 10.02 9.63 6.5 0 8.85

25 Total Phosphorous mg/lit NS NS 0.16 0 0.5 0.13 Nil 0.37 0.11 Nil

26 Dissolved Oxygen mg/lit NS NS 2.6 2.3 2.7 2.2 3.6 2.9 3.1 2.6



S. No. Parameters Unit

IS 10500 Standard Limits for drinking

water Ground Water Quality

Desirable

limit

Permissible

limit

GW1- Near Village

Pond Dabhasa

GW2- Near Gram Panchayat

Luna

GW3- Near Water

tank Ekalbara

GW4- Near

Temple Umraya

GW5- Near Gram panchayat Mahuvad


Luna


Luna

GW8- Nana Ekalbara

Road

Source Hand pump New Borewell Hand pump Hand

pump Hand pump

Old Borewell

Hand pump Hand pump

Date of Sampling 15/4/11 17/4/11 26/4/11 26/4/11 27/4/11 28/4/11 28/4/11 28/4/11

27 Heavy Metals

a Arsenic (as As) mg/l 0.05 NR <0.03 <0.03 <0.03 <0.03 <0.03 <0.03 <0.03 <0.03

b Cadmium (as Cd) mg/l 0.01 NR 0.01 0.01 0.01 <0.001 0.01 0.006 0.002 0.01

c Cromium (as Cr) mg/l 0.05 NR <0.01 <0.01 <0.01 <0.01 <0.01 <0.01 <0.01 <0.01

d Copper (as Cu) mg/l 0.05 1.5 <0.003 <0.003 <0.003 <0.003 <0.003 <0.003 0.05 <0.003

e Iron (as Fe) mg/l 0.3 1 Nil Nil Nil 1.14 0.23 0.058 Nil 0.41

f Lead (as Pb) mg/l 0.05 NR 0.10 <0.02 <0.02 0.18 0.08 <0.02 0.09 0.12

g Mercury (as Hg) mg/l 0.001 NR <0.0008 <0.0008 <0.0008 <0.0008 <0.0008 <0.0008 <0.0008 <0.0008

h Manganese (as Mn) mg/l 0.1 0.3 <0.007 <0.007 <0.007 <0.007 <0.007 <0.007 <0.007 <0.007

i Nickel (as Ni) mg/l - - <0.07 0.03 0.03 <0.07 1.42 0.1 0.0 0.08

j Zinc (as Zn) mg/l 5 15 0.48 2.1 0.04 0.09 2.01 0.16 0.01 0.04

28 Total Coliform MPN 10/100 ml 10/100 ml <2 <2 <2 <2 <2 <2 <2 <2

29 Faecal Coliforms MPN 10/100 ml 10/100 ml <2 <2 <2 <2 <2 <2 <2 <2

30 cyanide (cn) mg/lit Nil Nil Nil Nil Nil Nil Nil Nil

31 Boron mg/lit 0.30 0.09 0.95 1 0.93 1.01 1.03 0.59

32 colour Pt co 3 2 15 10 5 30 4 10

33 odour - none none none none none none none none

34 Re chlorine mg/lit Nil Nil Nil Nil Nil Nil Nil Nil Note: NA - Not Applicable, NR - No Relaxation, NS - Not Specified