Embed Size (px)
Citation preview
Page: 1 of 10
ALIGNMENTSPECIFICATION FOR
RS2640
Copyrighted Thomson Inc.
PAGE: 2 of 10
Rev Date Revision Text Changed By0 Jan-02-2002 First issue.
1 Oct-07-2003 1. Change adjust MW Osc coil (TF003) to obtain 1.51
±0.01V at TP 002 to adjust LW OSC coil( TF004)
to ……..
2. Add EA version
Ye Lun
PAGE: 3 of 10
TABLE OF CONTENTS
TUNER BOARD ALIGNMENT
1 FM IF ALIGNMENT 4
2 FM OSCILLATOR AND RF ALIGNMENT 5
3 FM STEREO ALIGNMENT 6
4 AM OSC ALIGNMENT 7
5 AM IF AND AFC ALIGNMENT 8
6 AM RF ALIGNMENT 9
MAIN BOARD TAPE ALIGNMENT (SEMI- ENCASING)
1 Azimuth Alignment 102 Tape Speed Adjustment 10
PAGE: 4 of 10
TUNER BOARD ALIGNMENT
1 FM IF ALIGNMENT
1. Testing conditions (remove the probe of counter during “S” curve align.)
INPUT TP 001 TP001G (RFGND)
OUTPUT TP 003 TP 009G (AGND)
1. Send a FM IF signal through a 1nF capacitor series with a 10K resistor to TP004 (Pin 39 of U1).
2. Detect the IF signal output at TP009 (Pin 10 of U1) through a 4.7 uF capacitor.
3. Align TF006 to obtain a clear display on the oscilloscope without any interference.
4. Ensure that the curve is not saturated.
5. Tune the set to 98.10 MHz
6. Apply an un-modulated mono RF signal at 98.10 MHz with RF input level of 1 mV.
7. Connect a frequency counter to TP003 (Pin 33 of IC001) thru a capacitor 0.1 uF
8. Check TP003 and align TF006 to get US model (10.7 MHz ± 10 KHz). EU/EA model (10.7MHz ±5kHz)
9 Feed a signal 38 dBf, 98.10 MHz (through matching balanced pad) from the signal generator to the antenna input of the set under test.
PAGE: 5 of 10
TUNER
4.7uF
IN OUT
10.60
10.70
10.80
TP-004
TP-004G
TP-009
FIGURE 1 FIGURE 2
TP-009G
1 nF 10K
2 FM OSCILLATOR AND RF ALIGNMENT
1. Testing Conditions:
INPUT TP 001 TP001G (RFGND)OUTPUT TP 007/ TP008 TP009G (AGND)TUNING VOLTAGE VT TP 002 TP009G (AGND)
1. Set frequency to 87.5 MHz.Adjust FM Osc coil (L004) to obtain 1.0 ~ 1.05 V at TP 002
2. Set frequency to 108.10 MHz.Adjust Vari-Cap (CV002) to obtain 7.0 ±0.5 at TP002.
3. Repeat the above procedure until the band coverage is fall within the specified VT voltage.
4. Feed a FM RF signal to a matching balanced pad of (50 ohm - 75 ohm) at TP 001 and RFGND.
5. Detect signal from TP 007/008 through the following circuit (Fig 3).
6. Set frequency to 90.10 MHz and adjust L003 until maximum amplitude is reached.
7. Set frequency to 106.10 MHz to see whether approximate amplitude is acquired.
8. Check the amplitude of 98.10 MHz for equal sensitivity.
PAGE: 6 of 10
TUNER
GENESCOPE
DC Voltmeter
IN OUT
TP-001
TP-001G
TP-007/008
TP-009G
4.7uF
FIGURE 3
TP-0021.00V TP-009G
3 FM STEREO ALIGNMENT
98.10MHz
TP-001TP-001G
TP-005
TP-006
152.000kHz
Frequency Counter
TUNER SECTION
FIGURE 5
FM Signal Generator
TP-010
RV-001
1. Testing Conditions: (Remove the VT probe during search)
INPUT TP 001 TP001G (RFGND)OUTPUT TP 005 TP010G (DGND)
2. Apply an un-modulated mono RF signal at 98.10 MHz with RF input level of 1 mV.
3. Search to 98.10 MHz
PAGE: 7 of 10
4. Connect a frequency counter to TP005 (Pin 24 of IC001), short TP010 (Pin 27 of IC001) to ground TP010G (Pin 26 of IC001) and across a resistor 10K from TP005 to GND
5. Check TP005 and align RV001 to get 152 KHz ± 1 KHz.
6. After the FM stereo alignment, sent a stereo 98.10 MHz signal to the set. Ensure the Stereo indicator lights up. The signal strength must not be more than 32 dB.
4 AM OSCILLATOR ALIGNMENT
1. Testing Conditions:
INPUT Ant Loop TP001G (RFGND)OUTPUT TP 007/ TP008 TP009G (AGND)TUNING VOLTAGE VT TP 002 TP009G (AGND)
MW2. Set frequency to 530 KHz (US version) & 522 KHz (EU/EA version)
Adjust MW Osc coil (TF003) to obtain 1.4 ± 0.05V at TP 002 for US versionAdjust MW Osc coil (TF003) to obtain 1.35 ± 0.05V at TP 002 for EU/EA version
3. Set frequency to 1710 KHz (US version) & 1611KHz (EU/EA version)Ensure the MW-VT at TP002 is 8.0 ± 1 V
LW4. Set frequency to 150 KHz.
Adjust LW Osc coil (TF004) to obtain 1.51 ±0.01V at TP 002
5 Set frequency to 283 KHzEnsure the LW-VT at TP002 is 4.6 ± 1V
PAGE: 8 of 10
5 AM IF AND AFC ALIGNMENT1. Testing Conditions: (remove the VT probe during search)
INPUT Ant Loop TP006OUTPUT TP011 TP004G (IFGND)
2. Send a AM IF signal to TP012 (pin6 of IC001)
3. Detect the signal out at TP009 as below figure 6
4. Adjust TF005 & TF008 until maximal amplitude reached
5. Send an un-modulated RF signal at 1000 KHz (EU version: 999KHz) with RF level of 100mV.
6. Search up/down the receiver. It will stop after acquiring this signal.
7. Connect a frequency counter to TP011 (Pin 36 of IC001) thru a capacitor 1uF
8. Check TP011 and align TF007 to get 450 KHz ± 1 KHz.
PAGE: 9 of 10
TUNER
4.7uF
IN OUT
445
450
455
TP-012
TP-004G
TP-009
FIGURE 6
TP-009G
1uF
6 AM RF ALIGNMENT
1. Testing Conditions:
INPUT Ant LoopOUTPUT TP 007/ TP008 TP009G (AGND)
MW1. Send a modulated (400 Hz) MW RF signal at 630 KHz with low RF level of 300 uV.
2. Detect signal from TP 007/008 and adjust TF001 until maximum amplitude is reached.
LW
7. Send a modulated (400 Hz) MW RF signal at 170 KHz with low RF level of 300 uV.
3. Detect signal from TP 007/008 and adjust TF002 until maximum amplitude is reached.
PAGE: 10 of 10
MAIN BOARD TAPE ALIGNMENT (SEMI-ENCASING)
Alignment for the cassette portion should be done at the semi - encased stage.
1 AZIMUTH ALIGNMENT
1. In tape transport 1, playback a test tape (TCC-153) of freq. 10 KHz
2. Connect the output to an oscilloscope and a voltmeter.
3. Adjust the azimuth screw at tape head to obtain maximum amplitude on both channels. (Both channels must be in phase).
4. Repeat the above procedure with tape transport 2.
2 TAPE SPEED ADJUSTMENT
1. Rewind test tape (MTT-111 DN 3khz) until both the left and right hubs are of equal spool.
2. Connect the output to the WOW -FLUTTER METER.
3. Adjust the trimmer in motor to obtain playback freq. of 3KHz ± 60 Hz if necessary
PAGE: 11 of 10
4. Stop transport 1 and playback the same test tape on transport 2.
5. Check the output and result must be the same as transport 1, if not, repeat the item 3
3 RECORD BIAS OSCILLATOR ALIGNMENT
1. Place a tape inside the set. Ensure that the tape is not record protected.
2. Select Tape mode and engage the Record button.
3. Monitor TP60 and TP60G (as ground). Ensure that the scope/meter does not have an activated low pass filter. Adjust L302 & L303 to obtain the voltage of 12Vrms±5% (9v ±1Vrms for A3080 andfrequency should be 58kHz ± 5%).
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing Notes00002 255412 CD PLATTER, 5-DISC CD MECH RS2640B 5506645000003 248366 CD BASE PLASTIC CD MECH RS2640B 209800000001 265140 PULLEY CD MECH RS2640B 209874700002 265139 PULLEY CD MECH RS2640B 209874800003 265137 WORM GEAR CD MECH RS2640B 2098749000052 N/S/P AC ASSEMBLY CDM5B DRAWER CD MECH RS2640B 209874600020 248152 DRAWER CD PLASTIC CDM5B CD MECH RS2640B 209799900025 238383 ROLLER, RUBBER BLACK 4X10 MM CD MECH RS2640B 207121200030 262534 HUB, ROLLER CD MECH RS2640B 207121700035 255882 BRACKET, SPIN MOTOR CD MECH RS2640B 209798600040 267098 CABINET FRONT INSTRUMENT ASSEMBLY RS2640B 552742200040 238376 MOTOR CD CAROUSEL CD MECH RS2640B 205818200045 248153 PULLEY MOTOR CD MECH RS2640B 209798700050 N/S/P SCREW 2MM 3MM JIS B 1111 53 0 0 CD MECH RS2640B 203495100050 267143 AC MLD CABINET BOTTOM RS2640B INSTRUMENT ASSEMBLY RS2640B 559386400055 251504 PLASTIC BUSHING CD MECH RS2640B 209799600060 248154 PULLEY WORM CD MECH RS2640B 209798800060 261259 CABINET LEFT INSTRUMENT ASSEMBLY RS2640B 556684600065 248155 WORM PLASTIC CD MECH RS2640B 209798900068 253163 SHAFT, WORM CD MECH RS2640B 209799000070 261260 CABINET RIGHT INSTRUMENT ASSEMBLY RS2640B 556684700073 248156 GEAR DUAL WORM CD MECH RS2640B 209797800080 238377 BELT, PLATTER ID 23MM CD MECH RS2640B 207101600080 267142 AC MLD CABINET BACK RS2640B INSTRUMENT ASSEMBLY RS2640B 559386500090 261262 CABINET TOP INSTRUMENT ASSEMBLY RS2640B 556684800100 257334 HOLDER VFD DISPLAY MAIN CBA RS2640B 552218200100 267078 DOOR CASS RS2640 INSTRUMENT ASSEMBLY RS2640B 553780200120 261265 DOOR CD INSTRUMENT ASSEMBLY RS2640B 556008300130 267079 BUTTON CASS STOP/EJECT INSTRUMENT ASSEMBLY RS2640B 555556200135 257760 MOTOR DRAWER CD MECH RS2640B 205818000140 N/S/P SCREW 2.6MM 5MM JIS B 1111 53 0 0 CD MECH RS2640B 203495400150 267080 BUTTON CASS PLAY RS2640 INSTRUMENT ASSEMBLY RS2640B 555628400150 248157 GEAR PULLEY CD MECH RS2640B 209798400155 265333 GEAR DUAL CD MECH RS2640B 209797700160 248159 GEAR, PIVOT CD MECH RS2640B 209798300165 248160 ARM SWING PLASTIC CD MECH RS2640B 209799400170 248161 GEAR, IDLER CD MECH RS2640B 209797900170 267081 BUTTON CASS RECORD RS2640 INSTRUMENT ASSEMBLY RS2640B 558582200175 248162 GEAR, CLUTCH CD MECH RS2640B 209797500180 267082 BUTTON CASS REWIND RS2640 INSTRUMENT ASSEMBLY RS2640B 558582400180 248163 ROLLER, SLIDING CD MECH RS2640B 209799500185 248164 GEAR, DUAL IDLER CD MECH RS2640B 209797600190 267083 BUTTON CASS FFWD RS2640 INSTRUMENT ASSEMBLY RS2640B 558582600190 248165 GEAR, MAIN CD MECH RS2640B 209798000200 267084 BUTTON CASS PAUSE RS2640 INSTRUMENT ASSEMBLY RS2640B 558582800200 248166 CAM, SLIDER CD MECH RS2640B 209797400208 253164 SPRING, TORSION MAIN CD MECH RS2640B 209798100210 265158 BUTTON, VOLUME UP/DOWN INSTRUMENT ASSEMBLY RS2640B 558583100210 248371 BRACKET PICK-UP CD MECH RS2640B 209799700220 248108 BELT, DRIVE ID 36MM CD MECH RS2640B 550733500220 267085 BUTTON 13KEYS+RING FRONT P INSTRUMENT ASSEMBLY RS2640B 558583400222 251571 SPRING RETENTION CD MECH RS2640B 209798500225 261320 ABSORBER, RUBBER GRAY CD MECH RS2640B 203650700230 245154 CUSHION, CD BLUE CD MECH RS2640B 204467400230 261276 BUTTON POWER/ON INSTRUMENT ASSEMBLY RS2640B 555368000235 248373 ARM PLASTIC MAGNETIC ROTATION CD MECH RS2640B 209799800240 261277 BUTTON OPEN/CLOSE/BASE INSTRUMENT ASSEMBLY RS2640B 555368200240 257371 HOLDER MAGNET COVER CD MECH RS2640B 552574800241 257372 HOLDER MAGNET BASE CD MECH RS2640B 553810400250 267086 BUTTON PRESET/EQ RS2640 INSTRUMENT ASSEMBLY RS2640B 558583600252 245153 MAGNET CD MECH RS2640B 204958300300 267087 BUTTON VOLUME RING RS2640 INSTRUMENT ASSEMBLY RS2640B 558583700310 267088 DOOR RING CASS RS2640 INSTRUMENT ASSEMBLY RS2640B 558583800320 267089 DOOR CASS ROUND RS2640 INSTRUMENT ASSEMBLY RS2640B 558588600320 257285 GEAR BOSS SUPPORT METAL CD MECH RS2640B 551892500322 N/S/P WASHER 3.2MM 7MM 0.5MM 3 00 0 A4 CD MECH RS2640B 552188100330 267099 COVER CASS ROUND RS2640 INSTRUMENT ASSEMBLY RS2640B 558584100373 253167 BRACKET CD MECH RS2640B 209798200380 N/S/P SCREW-ST 3MM 10MM JIS B 1122 25 0 0 CD MECH RS2640B 206923100385 N/S/P SCREW-ST 3MM 8.0MM JIS B 1122 53 0 0 CD MECH RS2640B 206561100390 260304 WASHER METAL CD MECH RS2640B 210141100401 248367 PAD NON-METAL FRICTION CD MECH RS2640B 550280100410 265151 CRYSTAL WITH RCA LOGO INSTRUMENT ASSEMBLY RS2640B 558415900420 253169 RUBBER STOPPER CD MECH RS2640B 210140500420 267100 CRYSTAL DISPLAY RS2640 INSTRUMENT ASSEMBLY RS2640B 558584500430 265154 CD DOOR INSERT INSTRUMENT ASSEMBLY RS2640B 558584700440 267101 CRYSTAL CONTROL PANEL RS2640 INSTRUMENT ASSEMBLY RS2640B 558584900460 265141 HOLDER CASS DOOR INSTRUMENT ASSEMBLY RS2640B 559235400460 261321 BUFFER 8.0X4.8X2.5 CD MECH RS2640B 550200300470 265147 MLD CASSETTE BOARD STANDOFF INSTRUMENT ASSEMBLY RS2640B 55851210
Page 1 of 11
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing Notes0480 249224 FOOT RUBBER SQUARE 4.8X11 MM CD MECH RS2640B 550746200485 261436 BRACKET PRESS CASS INSTRUMENT ASSEMBLY RS2640B 555358800500 253170 SPRING,PRESSURE 4TURNS 10 MM H CD MECH RS2640B 551052100510 261293 SPRING CASS INSTRUMENT ASSEMBLY RS2640B 551221100530 252829 FOOT RUBBER INSTRUMENT ASSEMBLY RS2640B 551114500560 267102 COVER FAN RS2640 INSTRUMENT ASSEMBLY RS2640B 558589700600 267103 GEAR DAMPER INSTRUMENT ASSEMBLY RS2640B 5591059AAMANT 255415 ANTENNA AND HOLDER AM INSTRUMENT ASSEMBLY RS2640B 55115970C001 157199 CAPCD 22PF J NP0 50V DRIVER BOARD ASY RS2640B 80434590C001 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560C002 260952 CAP CC 100NF 10% 25V Y5R DRIVER BOARD ASY RS2640B 20246950C003 157199 CAPCD 22PF J NP0 50V DRIVER BOARD ASY RS2640B 80434590C003 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560C004 260952 CAP CC 100NF 10% 25V Y5R DRIVER BOARD ASY RS2640B 20246950C004 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560C005 260634 CAP LYTC 470UF +20% 16.0V 85C DRIVER BOARD ASY RS2640B 20718370C006 240934 CAPCD .01UF K Y5P 50V DRIVER BOARD ASY RS2640B 70428520C007 249349 CE 4.7UF 20% 50V 85C MAIN CBA RS2640B 20268870C008 249340 CAPCE 100U0F 20% 10V 85C MAIN CBA RS2640B 20268940C010 256817 CAP CC 47PF 50V NPO MAIN CBA RS2640B 20506570C011 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380C012 200538 CAPCC 15PF J NPO 50V MAIN CBA RS2640B 20468940C013 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040C014 256827 CAP CC .47UF 10V Y5V MAIN CBA RS2640B 21022740C015 260668 CAP POLY 100NF +10% 50V MAIN CBA RS2640B 20266460C016 256827 CAP CC .47UF 10V Y5V MAIN CBA RS2640B 21022740C019 260615 CAPCC 1UF +80% -20% 10V MAIN CBA RS2640B 20811460C020 253714 CAPCC 470PF 5% 50V MAIN CBA RS2640B 20506680C021 256814 CAPCC 22PF +5% -5% 50V NPO MAIN CBA RS2640B 20506520C022 256827 CAP CC .47UF 10V Y5V MAIN CBA RS2640B 21022740C023 256827 CAP CC .47UF 10V Y5V MAIN CBA RS2640B 21022740C024 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840C025 256775 CAP CC .01UF K X7R 50V MAIN CBA RS2640B 10138960C026 256775 CAP CC .01UF K X7R 50V MAIN CBA RS2640B 10138960C027 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C028 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380C029 243464 CAPCC 15PF 5% 50V MAIN CBA RS2640B 20678050C030 256827 CAP CC .47UF 10V Y5V MAIN CBA RS2640B 21022740C031 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C032 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840C033 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840C034 260924 CAP LYTC 33UF +20% 25V 85C MAIN CBA RS2640B 20247150C035 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C036 260933 CAPCC 12PF 20% 50V MAIN CBA RS2640B 10137170C041 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C043 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040C045 256817 CAP CC 47PF 50V NPO MAIN CBA RS2640B 20506570C046 253714 CAPCC 470PF 5% 50V MAIN CBA RS2640B 20506680C047 256817 CAP CC 47PF 50V NPO MAIN CBA RS2640B 20506570C050 260636 CAP POLY 100NF +10% 50.0V MAIN CBA RS2640B 20936070C060 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560C061 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C062 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C099 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C300 249340 CAPCE 100U0F 20% 10V 85C CASSETTE CIRCUIT RS2640B 20268940C301 260929 CAP POLY 33NF +5% 50V CASSETTE CIRCUIT RS2640B 20266410C301L 265127 CAP POLY 1800PF +5% 50.0V CASSETTE CIRCUIT RS2640B 20351650C301R 265127 CAP POLY 1800PF +5% 50.0V CASSETTE CIRCUIT RS2640B 20351650C302 260927 CAP POLY 6.8NF +10% 50V CASSETTE CIRCUIT RS2640B 20266280C302L 260668 CAP POLY 100NF +10% 50V CASSETTE CIRCUIT RS2640B 20266460C302R 260668 CAP POLY 100NF +10% 50V CASSETTE CIRCUIT RS2640B 20266460C303 260928 CAP POLY 68NF +10% 50V CASSETTE CIRCUIT RS2640B 20266570C303L 249340 CAPCE 100U0F 20% 10V 85C CASSETTE CIRCUIT RS2640B 20268940C303R 249340 CAPCE 100U0F 20% 10V 85C CASSETTE CIRCUIT RS2640B 20268940C304 189981 CAP LYTC 10UF M 50V CASSETTE CIRCUIT RS2640B 20268880C304L 189981 CAP LYTC 10UF M 50V CASSETTE CIRCUIT RS2640B 20268880C304R 189981 CAP LYTC 10UF M 50V CASSETTE CIRCUIT RS2640B 20268880C305 260926 CAP LYTC 22UF +20% 25V 85C CASSETTE CIRCUIT RS2640B 20268890C305L 262520 CAPCD 220PF K Z5P 50V CASSETTE CIRCUIT RS2640B 70428370C305R 262520 CAPCD 220PF K Z5P 50V CASSETTE CIRCUIT RS2640B 70428370C306 249340 CAPCE 100U0F 20% 10V 85C CASSETTE CIRCUIT RS2640B 20268940C306L 265126 CAP POLY .047UF +5% 50.0V CASSETTE CIRCUIT RS2640B 20266440C306R 265126 CAP POLY .047UF +5% 50.0V CASSETTE CIRCUIT RS2640B 20266440C308L 194673 CAP LYTC 1UF M 50V CASSETTE CIRCUIT RS2640B 20268840C308R 194673 CAP LYTC 1UF M 50V CASSETTE CIRCUIT RS2640B 20268840C309L 143881 CAPCD 2200PF K Z5P 50V CASSETTE CIRCUIT RS2640B 11055540C309R 143881 CAPCD 2200PF K Z5P 50V CASSETTE CIRCUIT RS2640B 11055540C400 249340 CAPCE 100U0F 20% 10V 85C MAIN CBA RS2640B 20268940C400L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C400R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850
Page 2 of 11
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing NotesC401L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C401R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C402 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380C402L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C402R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C403 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380C404L 260935 CAPCC 5.6NF 10% 50V XR MAIN CBA RS2640B 10138730C404R 260935 CAPCC 5.6NF 10% 50V XR MAIN CBA RS2640B 10138730C407L 262523 CAP CC 150NF 10% 16V MAIN CBA RS2640B 20797500C407R 262523 CAP CC 150NF 10% 16V MAIN CBA RS2640B 20797500C408L 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C408R 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C409L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C409R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C410 260930 CAP LYTC 47UF +20% 25V 85C MAIN CBA RS2640B 20268910C410L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C410R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C411 249352 CAPLYTC 220UF 20% 16V 85C MAIN CBA RS2640B 20252650C412 237535 CE 22U0F +20% 100V 85C MAIN CBA RS2640B 13074800C414L 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550C414R 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550C420 249339 CAPCE 7UF +20% 10V 85C MAIN CBA RS2640B 20268930C430 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C453L 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C453R 260659 CAP LYTC 2.2FU +20% 50V 85C MAIN CBA RS2640B 20268850C501L 260938 CAPCC 5PF 10% 50V MAIN CBA RS2640B 20719320C501R 260938 CAPCC 5PF 10% 50V MAIN CBA RS2640B 20719320C502 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380C502L 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840C502R 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840C503 260930 CAP LYTC 47UF +20% 25V 85C MAIN CBA RS2640B 20268910C505L 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550C505R 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550C507L 253714 CAPCC 470PF 5% 50V MAIN CBA RS2640B 20506680C507R 253714 CAPCC 470PF 5% 50V MAIN CBA RS2640B 20506680C509L 260930 CAP LYTC 47UF +20% 25V 85C MAIN CBA RS2640B 20268910C509R 260930 CAP LYTC 47UF +20% 25V 85C MAIN CBA RS2640B 20268910C512 267091 CAP 4.7MF +20% 50.0V 85C MAIN CBA RS2640B S 55854010C513 267091 CAP 4.7MF +20% 50.0V 85C MAIN CBA RS2640B S 55854010C514 260637 CAP LYTC 2200UF 25.0V 85C MAIN CBA RS2640B 13048060C515 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890C516 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890C518 202011 CAP POLY .1UF J 63V MAIN CBA RS2640B 20780350C518L 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C518R 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C520 202011 CAP POLY .1UF J 63V MAIN CBA RS2640B 20780350C521L 267075 CPM 330N0F +5% 50.0V MAIN CBA RS2640B 13087290C521R 267075 CPM 330N0F +5% 50.0V MAIN CBA RS2640B 13087290C522L 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550C522R 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550C523 260952 CAP CC 100NF 10% 25V Y5R MAIN CBA RS2640B 20246950C524 202011 CAP POLY .1UF J 63V MAIN CBA RS2640B 20780350C533 202011 CAP POLY .1UF J 63V MAIN CBA RS2640B 20780350C534 189981 CAP LYTC 10UF M 50V MAIN CBA RS2640B 20268880C535 189981 CAP LYTC 10UF M 50V MAIN CBA RS2640B 20268880C537 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890C538 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890C539 249823 CAPLYTC 100UF 20% 50V 85C MAIN CBA RS2640B 13074540C540 249823 CAPLYTC 100UF 20% 50V 85C MAIN CBA RS2640B 13074540C541 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C542 256770 CAP CC 100PF +10% -10% 50V NPO MAIN CBA RS2640B 10137380C600 260670 CAP LYTC 470UF +20% 10V 85C MAIN CBA RS2640B 20252670C604L 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890C604R 260926 CAP LYTC 22UF +20% 25V 85C MAIN CBA RS2640B 20268890C605L 249340 CAPCE 100U0F 20% 10V 85C MAIN CBA RS2640B 20268940C605R 249340 CAPCE 100U0F 20% 10V 85C MAIN CBA RS2640B 20268940C611L 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840C611R 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840C701 249339 CAPCE 7UF +20% 10V 85C MAIN CBA RS2640B 20268930C702 249340 CAPCE 100U0F 20% 10V 85C MAIN CBA RS2640B 20268940C704 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040C705 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040C705A 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040C706 260670 CAP LYTC 470UF +20% 10V 85C MAIN CBA RS2640B 20252670C707 256811 CAPCC .047UF 50V Y5V MAIN CBA RS2640B 20288010C708 256811 CAPCC .047UF 50V Y5V MAIN CBA RS2640B 20288010C711 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560C712 256816 CAP CC 33PF 50V NPO MAIN CBA RS2640B 20506560C713 194673 CAP LYTC 1UF M 50V MAIN CBA RS2640B 20268840C714 256814 CAPCC 22PF +5% -5% 50V NPO MAIN CBA RS2640B 20506520
Page 3 of 11
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing NotesC715 256814 CAPCC 22PF +5% -5% 50V NPO MAIN CBA RS2640B 20506520C721 256811 CAPCC .047UF 50V Y5V MAIN CBA RS2640B 20288010C725 256818 CAP CC 100PF 50V NPO MAIN CBA RS2640B 20506590C726 256818 CAP CC 100PF 50V NPO MAIN CBA RS2640B 20506590C730 249339 CAPCE 7UF +20% 10V 85C MAIN CBA RS2640B 20268930C750 256811 CAPCC .047UF 50V Y5V MAIN CBA RS2640B 20288010C751 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040C753 260642 CAPCC 100NF +80% -20% 16V Y5V MAIN CBA RS2640B 20288040C755 253796 CAPCC .1UF 10% 16V MAIN CBA RS2640B 20947390C790 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550C791 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550C792 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550C793 249336 CAPCC 1NF 10% 50V X7R MAIN CBA RS2640B 10138550C805 249823 CAPLYTC 100UF 20% 50V 85C MAIN CBA RS2640B 13074540C806 249823 CAPLYTC 100UF 20% 50V 85C MAIN CBA RS2640B 13074540C807 267090 CAP 100NF +80% -20% 50V Y5V MAIN CBA RS2640B 20267290C901 194673 CAP LYTC 1UF M 50V CASSETTE CIRCUIT RS2640B 20268840CD MEC 267112 CD MECHANISM CD MECH RS2640B 55843210CD MOD 267145 CDM5B CD MECH TCM-135 INSTRUMENT ASSEMBLY RS2640B 55947050CIR 267144 AC SINGLE TAPE-DECK MODULE INSTRUMENT ASSEMBLY RS2640B 55831110CV001 260944 CAP TRIM 3PF 11.0F 100 N450 MAIN CBA RS2640B 20969010CV002 260944 CAP TRIM 3PF 11.0F 100 N450 MAIN CBA RS2640B 20969010CY03 195922 CAPCC 330PF 10% 50V MAIN CBA RS2640B 10138480D001 246124 DIODE SVC201SPA MAIN CBA RS2640B 20677870D001 246515 DIODE ZENER 0.5W Z5V6 DRIVER BOARD ASY RS2640B 20414280D002 246124 DIODE SVC201SPA MAIN CBA RS2640B 20677870D002 246343 DIODE ZENER 6.8V 1/2W IN5235B DRIVER BOARD ASY RS2640B 20526990D003 260293 DIODE SLPVC KV1270NT 16.0V MAIN CBA RS2640B 55235610D003 257370 DIODE 1N4002 100.0V 1A DRIVER BOARD ASY RS2640B 20415050D004 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D004 257370 DIODE 1N4002 100.0V 1A DRIVER BOARD ASY RS2640B 20415050D005 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D401 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D402 248145 DIODE ZENER 7.5V 1/2W BZX55C7V MAIN CBA RS2640B 80444150D501 248140 DIODE ZENER 5.1V 1/2W 1N5231B MAIN CBA RS2640B 20526960D502L 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D502R 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D503 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D504 261441 D-ZENER 1N5221B 2.4V 1/2W MAIN CBA RS2640B 20845050D505 249217 DIODE 1N5402 200.0V 3.0A MAIN CBA RS2640B 55041640D506 249217 DIODE 1N5402 200.0V 3.0A MAIN CBA RS2640B 55041640D507 249217 DIODE 1N5402 200.0V 3.0A MAIN CBA RS2640B 55041640D508 249217 DIODE 1N5402 200.0V 3.0A MAIN CBA RS2640B 55041640D509 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670D510 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670D511 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670D512 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670D513 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D515 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D516 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D701 223783 DIODE ZENER 6.2V .5W MAIN CBA RS2640B 20475410D702 223783 DIODE ZENER 6.2V .5W MAIN CBA RS2640B 20475410D703 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D704 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D712 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D715 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D716 246244 DIODE LED MAIN CBA RS2640B 20971500D718 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D721 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D730 198589 DIODE 1N4148 MAIN CBA RS2640B 70436540D819 248145 DIODE ZENER 7.5V 1/2W BZX55C7V MAIN CBA RS2640B 80444150D820 257133 DIODE ZENER BZX85C27 27V 1.3W MAIN CBA RS2640B S 20741600D821 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670D822 198597 DIODE 1N4001 MAIN CBA RS2640B 20454670DECK 267111 CASSETTE DECK ASSEMBLY INSTRUMENT ASSEMBLY RS2640B 5584148AF503 246839 FUSE SB 5A/125V POWER AMP PCB RS2640B S 20828880F504 246839 FUSE SB 5A/125V POWER AMP PCB RS2640B S 20828880FAN 262981 FAN POWER AMP PCB RS2640B S 55634450FH503 252836 HOLDER FUSE MAIN CBA RS2640B 55017140FH504 252836 HOLDER FUSE MAIN CBA RS2640B 55017140FMANT NONSTK WIRE JUMPER INSTRUMENT ASSEMBLY RS2640B 55380950IC001 251852 IC FAN8082 DRIVER BOARD ASY RS2640B S 55116380IC001 217386 IC LB1641 DRIVER BOARD ASY RS2640B S 20656300IC001 252771 IC TEA5757H AM/FM REC MAIN CBA RS2640B 20955120IC002 217386 IC LB1641 DRIVER BOARD ASY RS2640B S 20656300IC002 251852 IC FAN8082 DRIVER BOARD ASY RS2640B S 55116380IC300 265124 IC, POWER AMP UTC7312 CASSETTE CIRCUIT RS2640B 55827080IC401 252772 IC TDA7440D AUDIO MAIN CBA RS2640B 55097860IC501 261309 IC-POWAMP TDA7293 POWER AMP PCB RS2640B 55512880IC502 261309 IC-POWAMP TDA7293 POWER AMP PCB RS2640B 55512880
Page 4 of 11
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing NotesIC503 251567 IC KIA7812API POWER AMP PCB RS2640B 55094390IC701 261444 IC - UPD780205AGF-018-38A MAIN CBA RS2640B 55547820IR701 265123 IC, REMOTE RECEIVER MAIN CBA RS2640B 55488350J101 NONSTK WIRE JUMPER CASSETTE CIRCUIT RS2640B 55210010J101 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J102 NONSTK WIRE JUMPER CASSETTE CIRCUIT RS2640B 55210010J102 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J103 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J104 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J105 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J106 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J107 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J108 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J109 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J110 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J111 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J112 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J113 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J114 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J115 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J116 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J117 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J118 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J119 NONSTK WIRE JUMPER CASSETTE CIRCUIT RS2640B 55210010J119 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J120 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J121 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J122 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J123 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J124 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J125 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J126 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J127 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J128 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J129 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J130 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010J201 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J202 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J203 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J204 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J205 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J206 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J207 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J208 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J209 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J210 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J211 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J212 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J213 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J214 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J215 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J216 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J217 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J218 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J219 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J220 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J221 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J222 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J224 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J225 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J226 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J227 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J228 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J229 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J230 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J231 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329200J301 NONSTK WIRE JUMPER CASSETTE CIRCUIT RS2640B 20181860J301 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J302 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J303 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J304 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J305 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J306 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J307 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J308 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J309 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J310 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J311 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J312 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J313 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860
Page 5 of 11
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing NotesJ314 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J315 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J316 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J317 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J318 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J319 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J320 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J321 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J322 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J323 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J324 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J325 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J326 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J327 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J328 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J329 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J330 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J331 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J332 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181860J401 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J402 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J403 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J404 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J405 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J406 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J407 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J408 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J409 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J410 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J411 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J412 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J413 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J414 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J415 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J416 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J417 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J418 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J419 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J420 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J421 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J422 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J423 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J424 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J425 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J426 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J427 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J428 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J429 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J430 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290J501 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J502 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J503 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J504 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J505 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J506 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J507 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J508 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J509 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J510 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J511 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J512 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J513 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J514 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J515 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J516 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J601 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J602 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J603 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J604 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J605 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J606 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J607 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J608 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J609 NONSTK WIRE JUMPER MAIN CBA RS2640B 20181870J610 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J611 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J612 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J613 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J614 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J615 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320
Page 6 of 11
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing NotesJ616 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J617 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J618 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J619 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J620 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J621 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J622 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J623 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J624 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J625 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J626 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J627 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320J628 NONSTK WIRE JUMPER MAIN CBA RS2640B 20637320JA001 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20535600JA002 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20535600JB001 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329200JB002 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329200JB003 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329200JB004 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329200JB006 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329200JC002 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181860JD001 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20329290JE001 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20637320JE002 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870JE003 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870JE004 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870JE005 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870JE006 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870JE007 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870JE008 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870JE009 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20181870JP02 256783 RES CMF 0 OHM 0% 1/16W MAIN CBA RS2640B 10328750L001 260945 COIL AIR 0.812MM 4.0MM 4.5 R MAIN CBA RS2640B 20289390L001 261319 COIL LF 39UH 10% 1.5A DRIVER BOARD ASY RS2640B 55326960L003 262528 COIL AIR MAIN CBA RS2640B 55156120L004 260947 COIL AIR .85MM 4.5MM 2.5 LEFT MAIN CBA RS2640B 55109060L007 190729 COIL 47UH MAIN CBA RS2640B 30944670L301 175411 COIL 220UH CASSETTE CIRCUIT RS2640B 40438480L302 261449 COIL LF 470UH +5% 7.7 OHM CASSETTE CIRCUIT RS2640B 13080530L303 261449 COIL LF 470UH +5% 7.7 OHM CASSETTE CIRCUIT RS2640B 13080530L501L 250600 COIL AIR 1MM 10MM 7 TURNS MAIN CBA RS2640B 21070690L501R 250600 COIL AIR 1MM 10MM 7 TURNS MAIN CBA RS2640B 21070690L602 NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290L602L NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290L602R NONSTK WIRE JUMPER MAIN CBA RS2640B 20329290L701 160186 COIL 100UH MAIN CBA RS2640B 30944680N002 249907 CONNECTOR 2.5MM 2 MA MAIN CBA RS2640B S 20366830N005 248206 CONN 2.0MM 9 MA DRIVER BOARD ASY RS2640B 20368920N006 255420 CABLE, 3P 220MM DRIVER BOARD ASY RS2640B 20365440N300 253190 CONNECTOR 4P CASSETTE CIRCUIT RS2640B 55109170N301 265134 CONNECTORS, 10 PIN CASSETTE CIRCUIT RS2640B 20368810N302 253190 CONNECTOR 4P CASSETTE CIRCUIT RS2640B 55109170N501 265218 CONNECTOR, 2-PIN MAIN CBA RS2640B 55078300N516 248203 CONN 2.5MM 3P MAIN CBA RS2640B 20368290N601 265131 CONNECTOR, 4 PIN MAIN CBA RS2640B 20368280N701 267093 CONNECTOR 6PIN MAIN CBA RS2640B 20368740N702 267094 CONNECTOR 2.5MM 9PIN MAIN CBA RS2640B 20368840N801B 265130 CONNECTOR, 5 PIN MAIN CBA RS2640B 55123640NJ501 248096 CONNECTOR SPEAKER 4X MAIN CBA RS2640B 20604680NJ503 248103 3.5MM PHONE JACK MAIN CBA RS2640B 20369030NJ504 262244 CON PHONO SCKT RCA 2 PINS MAIN CBA RS2640B 5554881AP-CORD 267071 WIRE BARE 22 POWER AMP PCB RS2640B S 55920140P001 267141 WCL UL1095 HOOK-UP MAIN CBA RS2640B 55879940P002 265132 CONNECTOR, 3 PIN DRIVER BOARD ASY RS2640B 20368710P003 265135 CONNECTOR, 6 PIN DRIVER BOARD ASY RS2640B 20683150P004 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20818500P005 250634 CABLE ASY 9P 220MM DRIVER BOARD ASY RS2640B S 55024510P006 265132 CONNECTOR, 3 PIN DRIVER BOARD ASY RS2640B 20368710P007 249907 CONNECTOR 2.5MM 2 MA DRIVER BOARD ASY RS2640B S 20366830P008 265128 CONNECTOR, 8 PIN DRIVER BOARD ASY RS2640B 20368720P009 265129 CONNECTOR, 7 PIN DRIVER BOARD ASY RS2640B 20366610P026 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20818500P027 252838 CABLE 6 PIN DRIVER BOARD ASY RS2640B 55089690P101 257276 CABLE 2P 360MM MAIN CBA RS2640B 20364270P300 267113 RIBBON CABLE CASSETTE CIRCUIT RS2640B 55843050P301 267095 CABLE 10 PIN 250MM MAIN CBA RS2640B 20685000P302 267114 RIBBON CABLE CASSETTE CIRCUIT RS2640B 55843040P401 257347 CABLE 3P 350MM MAIN CBA RS2640B 55092650P516 257204 CABLE 3P 280MM MAIN CBA RS2640B 20368990P601 262529 CABLE 4P 100MM MAIN CBA RS2640B 20365490
Page 7 of 11
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing NotesP701 267096 CABLE 6 PIN 220MM MAIN CBA RS2640B 20862510P702 267092 CABLE RIBBON MAIN CBA RS2640B S 55009710P705 257341 CABLE 7P 200MM MAIN CBA RS2640B 20939490P706 257342 CABLE 8P 200MM MAIN CBA RS2640B 55075100PI001 250652 DIODE-PHOTO RPI-576 DRIVER BOARD ASY RS2640B 55098050PI002 250652 DIODE-PHOTO RPI-576 DRIVER BOARD ASY RS2640B 55098050PI003 238359 DIODE PHOTO RPI-574 DRIVER BOARD ASY RS2640B 20586840PI004 251851 DIODE TYPE ITR2002 DRIVER BOARD ASY RS2640B 5508631API005 250652 DIODE-PHOTO RPI-576 DRIVER BOARD ASY RS2640B 55098050PI006 250652 DIODE-PHOTO RPI-576 DRIVER BOARD ASY RS2640B 55098050Q301 253887 TRANSISTOR KTC3203Y CASSETTE CIRCUIT RS2640B 20538220Q302 250627 TRANSISTOR KTA1271Y CASSETTE CIRCUIT RS2640B 20685080Q303 248202 TRANSISTOR 2SC1815Y CASSETTE CIRCUIT RS2640B 20508030Q401 253887 TRANSISTOR KTC3203Y MAIN CBA RS2640B 20538220Q410 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q410L 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q410R 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q501 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q502 250627 TRANSISTOR KTA1271Y MAIN CBA RS2640B 20685080Q503 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q602L 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q602R 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q603L 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q603R 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q701 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q702 253887 TRANSISTOR KTC3203Y MAIN CBA RS2640B 20538220Q703 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q704 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850Q705 248090 TRANSISTOR KTC3875GR MAIN CBA RS2640B 20779850R001 NONSTK WIRE JUMPER DRIVER BOARD ASY RS2640B 20535600R002 210245 RES CF 1/4W 5% 100R DRIVER BOARD ASY RS2640B 50882950R003 248167 RES CFF 2.2R 5% 1/4W DRIVER BOARD ASY RS2640B S 20549430R004 248167 RES CFF 2.2R 5% 1/4W DRIVER BOARD ASY RS2640B S 20549430R005 260685 RES CMF 56R +5% 1/16W MAIN CBA RS2640B 10134680R005 210245 RES CF 1/4W 5% 100R DRIVER BOARD ASY RS2640B 50882950R006 253139 RES CF 150R 5% 1/4W DRIVER BOARD ASY RS2640B 50882960R006 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220R007 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220R007 179297 RES CF 1/2W 5% 68R DRIVER BOARD ASY RS2640B 20469670R008 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220R009 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220R010 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860R011 256752 RES CMF 75K OHM 5% 1/16W MAIN CBA RS2640B 10135310R013 256757 RES CMF 220K OHM 5% 1/16W MAIN CBA RS2640B 10135420R014 256757 RES CMF 220K OHM 5% 1/16W MAIN CBA RS2640B 10135420R015 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860R017 256768 RES CMF 8.2K OHM 5% 1/16W MAIN CBA RS2640B 10136000R021 256768 RES CMF 8.2K OHM 5% 1/16W MAIN CBA RS2640B 10136000R030 256730 RES CMF 100 OHM 5% 1/16W MAIN CBA RS2640B 10134740R031 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R034 256725 RES CMF 22 OHM +5% 1/16W MAIN CBA RS2640B 10134540R035 256744 RES CMF 18K OHM 5% 1/16W MAIN CBA RS2640B 10135080R036 256756 RES CMF 150K OHM 5% 1/16W MAIN CBA RS2640B 10135380R045 256737 RES CMF 470 OHM 5% 1/16W MAIN CBA RS2640B 10134910R046 256737 RES CMF 470 OHM 5% 1/16W MAIN CBA RS2640B 10134910R047 256737 RES CMF 470 OHM 5% 1/16W MAIN CBA RS2640B 10134910R097 256730 RES CMF 100 OHM 5% 1/16W MAIN CBA RS2640B 10134740R300 175324 RES CF 1/4W 5% 220R CASSETTE CIRCUIT RS2640B 20469450R301 176801 RES CF 1/4W 5% 56K CASSETTE CIRCUIT RS2640B 11059710R301L 240936 RES CF 1/4W 5% 12K CASSETTE CIRCUIT RS2640B 90571120R301R 240936 RES CF 1/4W 5% 12K CASSETTE CIRCUIT RS2640B 90571120R302 175322 RES CF 1/4W 5% 47K CASSETTE CIRCUIT RS2640B 40435670R302L 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480R302R 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480R303L 265122 RES CF 7.5 OHMS 1/4 WATT CASSETTE CIRCUIT RS2640B 55223890R303R 265122 RES CF 7.5 OHMS 1/4 WATT CASSETTE CIRCUIT RS2640B 55223890R304 175361 RES CF 1/4W 5% 120R CASSETTE CIRCUIT RS2640B 11059600R304L 175308 RES CF 1/4W 5% 1.2K CASSETTE CIRCUIT RS2640B 80437000R304R 175308 RES CF 1/4W 5% 1.2K CASSETTE CIRCUIT RS2640B 80437000R305 175054 RES CF 1/4W 5% 22K CASSETTE CIRCUIT RS2640B 60441580R305L 175314 RES CF 1/4W 5% 33K CASSETTE CIRCUIT RS2640B 30939490R305R 175314 RES CF 1/4W 5% 33K CASSETTE CIRCUIT RS2640B 30939490R306 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480R306L 202069 RES CF 1/4W 5% 1K CASSETTE CIRCUIT RS2640B 11059640R306R 202069 RES CF 1/4W 5% 1K CASSETTE CIRCUIT RS2640B 11059640R307 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480R307L 239019 RES CF 1/4W 5% 220K CASSETTE CIRCUIT RS2640B 30939530R307R 239019 RES CF 1/4W 5% 220K CASSETTE CIRCUIT RS2640B 30939530R308 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480R309 175324 RES CF 1/4W 5% 220R CASSETTE CIRCUIT RS2640B 20469450
Page 8 of 11
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing NotesR310 175317 RES CF 1/4W 5% 10K CASSETTE CIRCUIT RS2640B 30939480R315L 175047 RCF 5K6 OHM +5% 250MI0W CASSETTE CIRCUIT RS2640B 70430560R315R 175047 RCF 5K6 OHM +5% 250MI0W CASSETTE CIRCUIT RS2640B 70430560R316L 175047 RCF 5K6 OHM +5% 250MI0W CASSETTE CIRCUIT RS2640B 70430560R316R 175047 RCF 5K6 OHM +5% 250MI0W CASSETTE CIRCUIT RS2640B 70430560R401 175769 RES CF 1/2W 5% 390R MAIN CBA RS2640B 70430860R401L 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R401R 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R402L 256765 RES CMF 5.6K OHM 5% 1/16W MAIN CBA RS2640B 10135960R402R 256765 RES CMF 5.6K OHM 5% 1/16W MAIN CBA RS2640B 10135960R403L 256765 RES CMF 5.6K OHM 5% 1/16W MAIN CBA RS2640B 10135960R403R 256765 RES CMF 5.6K OHM 5% 1/16W MAIN CBA RS2640B 10135960R407 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R408 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R410 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220R410L 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940R410R 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940R411 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R412 175317 RES CF 1/4W 5% 10K MAIN CBA RS2640B 30939480R413L 244090 RES CMF 7.5K 5% 1/10W MAIN CBA RS2640B 10135990R413R 244090 RES CMF 7.5K 5% 1/10W MAIN CBA RS2640B 10135990R414L 256764 RES CMF 3.3K OHM 5% 1/16W MAIN CBA RS2640B 10135900R414R 256764 RES CMF 3.3K OHM 5% 1/16W MAIN CBA RS2640B 10135900R420 260685 RES CMF 56R +5% 1/16W MAIN CBA RS2640B 10134680R501L 256748 RES CMF 33K OHM 5% 1/16W MAIN CBA RS2640B 10135170R501R 256748 RES CMF 33K OHM 5% 1/16W MAIN CBA RS2640B 10135170R502 256737 RES CMF 470 OHM 5% 1/16W MAIN CBA RS2640B 10134910R502L 256748 RES CMF 33K OHM 5% 1/16W MAIN CBA RS2640B 10135170R502R 256748 RES CMF 33K OHM 5% 1/16W MAIN CBA RS2640B 10135170R503 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R503L 243486 RES CMF 390 OHMS 5% 1/10W MAIN CBA RS2640B 10134890R503R 243486 RES CMF 390 OHMS 5% 1/10W MAIN CBA RS2640B 10134890R504 202069 RES CF 1/4W 5% 1K MAIN CBA RS2640B 11059640R505 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R506L 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R506R 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R507L 256754 RES CMF 100K OHM 5% 1/16W MAIN CBA RS2640B 10135340R507R 256754 RES CMF 100K OHM 5% 1/16W MAIN CBA RS2640B 10135340R509 220568 RES CF 1/4W 5% 10R MAIN CBA RS2640B 30939360R510 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R510L 220568 RES CF 1/4W 5% 10R MAIN CBA RS2640B 30939360R510R 220568 RES CF 1/4W 5% 10R MAIN CBA RS2640B 30939360R511 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R512 256767 RES CMF 6.8K OHM 5% 1/16W MAIN CBA RS2640B 10135980R512L 261306 RES CMF 4.7 OHM +5% 1/16W MAIN CBA RS2640B 20538660R512R 261306 RES CMF 4.7 OHM +5% 1/16W MAIN CBA RS2640B 20538660R525 256748 RES CMF 33K OHM 5% 1/16W MAIN CBA RS2640B 10135170R527 256783 RES CMF 0 OHM 0% 1/16W MAIN CBA RS2640B 10328750R529 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R530 267073 RESISTOR MAIN CBA RS2640B 90571460R531 267073 RESISTOR MAIN CBA RS2640B 90571460R532 256759 RES CMF 1.5K 5% 1/10W MAIN CBA RS2640B 10135820R600 175040 RES CF 1/4W 5% 47R MAIN CBA RS2640B 70430510R610L 262525 RES CMF 680K 5% 1/6W MAIN CBA RS2640B 10135570R610R 262525 RES CMF 680K 5% 1/6W MAIN CBA RS2640B 10135570R611L 256760 RES CMF 2K OHM 5% 1/16W MAIN CBA RS2640B 10135850R611R 256760 RES CMF 2K OHM 5% 1/16W MAIN CBA RS2640B 10135850R612L 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R612R 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R613L 256942 RES CMF 220 OHM 5% 1/16W MAIN CBA RS2640B 10134830R613R 256942 RES CMF 220 OHM 5% 1/16W MAIN CBA RS2640B 10134830R615L 249039 RES CMF 1.8K 5% 1/10W MAIN CBA RS2640B 10135840R615R 249039 RES CMF 1.8K 5% 1/10W MAIN CBA RS2640B 10135840R616L 176646 RES CF 1/4W 5% 180R MAIN CBA RS2640B 60441540R616R 176646 RES CF 1/4W 5% 180R MAIN CBA RS2640B 60441540R617L 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860R617R 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860R700 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R701 175312 RES CF 1/4W 5% 680R MAIN CBA RS2640B 11059630R702 256730 RES CMF 100 OHM 5% 1/16W MAIN CBA RS2640B 10134740R703 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R704 256730 RES CMF 100 OHM 5% 1/16W MAIN CBA RS2640B 10134740R705 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940R706 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940R707 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R708 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R709 256742 RES CMF 12K OHM 5% 1/16W MAIN CBA RS2640B 10135030R710 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220R712 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R714 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010
Page 9 of 11
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing NotesR716 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R717 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R718 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R725 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940R726 256760 RES CMF 2K OHM 5% 1/16W MAIN CBA RS2640B 10135850R728 256762 RES CMF 2.7K OHM 5% 1/16W MAIN CBA RS2640B 10135880R729 256759 RES CMF 1.5K 5% 1/10W MAIN CBA RS2640B 10135820R734 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R735 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R736 256764 RES CMF 3.3K OHM 5% 1/16W MAIN CBA RS2640B 10135900R737 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940R739 256751 RES CMF 68K OHM 5% 1/16W MAIN CBA RS2640B 10135290R740 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860R741 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R742 256761 RES CMF 2.2K OHM 5% 1/16W MAIN CBA RS2640B 10135860R743 256764 RES CMF 3.3K OHM 5% 1/16W MAIN CBA RS2640B 10135900R744 244090 RES CMF 7.5K 5% 1/10W MAIN CBA RS2640B 10135990R745 256753 RES CMF 82K OHM 5% 1/16W MAIN CBA RS2640B 10135320R746 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R747 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R748 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R749 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R750 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R751 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R752 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R753 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R754 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R755 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R756 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R757 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R759 249041 RES CMF 1.2K 5% 1/10W MAIN CBA RS2640B 10135790R760 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R761 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R762 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R763 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220R764 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R765 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220R766 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R767 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R768 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R769 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R770 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R771 256746 RES CMF 22K OHM 5% 1/16W MAIN CBA RS2640B 10135120R780 249338 RESMF 47K OHM +5% 62.5MW MAIN CBA RS2640B 10135220R783 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940R784 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940R786 256735 RES CMF 330 OHM 5% 1/16W MAIN CBA RS2640B 10134870R788 260305 RES CHIP 1K 5% 1/16W MAIN CBA RS2640B 10135770R790 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R791 256760 RES CMF 2K OHM 5% 1/16W MAIN CBA RS2640B 10135850R792 256768 RES CMF 8.2K OHM 5% 1/16W MAIN CBA RS2640B 10136000R793 243375 RES CMF 4.7K 5% 1/10W MAIN CBA RS2640B 10135940R794 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R795 249041 RES CMF 1.2K 5% 1/10W MAIN CBA RS2640B 10135790R796 256759 RES CMF 1.5K 5% 1/10W MAIN CBA RS2640B 10135820R797 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R798 249041 RES CMF 1.2K 5% 1/10W MAIN CBA RS2640B 10135790R799 256759 RES CMF 1.5K 5% 1/10W MAIN CBA RS2640B 10135820R805 256741 RES CMF 10K OHM 5% 1/16W MAIN CBA RS2640B 10135010R881 256435 RES CF 3.3M 10% 1/2W MAIN CBA RS2640B S 55180100R885 175317 RES CF 1/4W 5% 10K MAIN CBA RS2640B 30939480R886 176651 RES CF 1/2W 5% 220R MAIN CBA RS2640B 50883190R888 186819 RESISTOR 1R 5% 1/4W MAIN CBA RS2640B 11067570R889 NONSTK WIRE JUMPER MAIN CBA RS2640B 55210010REMO 267108 REM301-RS2640 REMOTE INSTRUMENT ASSEMBLY RS2640B 55237400RF505 262527 RES FUSE 1W MAIN CBA RS2640B S 55780020RV001 257759 RES VAR 47K0 OHM +25% MAIN CBA RS2640B 55276190SPK 267109 MAIN SPEAKER BOX ASSEMBLY INSTRUMENT ASSEMBLY RS2640B 55857990SW1 265121 SWITCH, ON/OFF CASSETTE CIRCUIT RS2640B S 55830210SW701 245481 SWITCH MAIN CBA RS2640B 20404730SW702 245481 SWITCH MAIN CBA RS2640B 20404730SW703 245481 SWITCH MAIN CBA RS2640B 20404730SW704 245481 SWITCH MAIN CBA RS2640B 20404730SW705 245481 SWITCH MAIN CBA RS2640B 20404730SW706 245481 SWITCH MAIN CBA RS2640B 20404730SW707 245481 SWITCH MAIN CBA RS2640B 20404730SW708 245481 SWITCH MAIN CBA RS2640B 20404730SW709 245481 SWITCH MAIN CBA RS2640B 20404730SW710 245481 SWITCH MAIN CBA RS2640B 20404730SW711 245481 SWITCH MAIN CBA RS2640B 20404730
Page 10 of 11
RS2640B
Symbol Stock Description Circuit Model TypeCode Drawing NotesSW712 245481 SWITCH MAIN CBA RS2640B 20404730SW713 245481 SWITCH MAIN CBA RS2640B 20404730SW714 245481 SWITCH MAIN CBA RS2640B 20404730SW715 245481 SWITCH MAIN CBA RS2640B 20404730SW716 245481 SWITCH MAIN CBA RS2640B 20404730SW717 245481 SWITCH MAIN CBA RS2640B 20404730SW718 245481 SWITCH MAIN CBA RS2640B 20404730T001 267072 TF POWER-TRANSFORMER 120V POWER AMP PCB RS2640B S 5551308ATF001 255404 COIL, ADJUSTABLE MAIN CBA RS2640B 55103950TF003 255405 COIL, ADJUSTABLE MAIN CBA RS2640B 55103970TF005 260949 COIL ADJUSTABLE MAIN CBA RS2640B 55624150TF006 255407 COIL, ADJUSTABLE MAIN CBA RS2640B 55103940TF007 260950 COIL ADJUSTABLE MAIN CBA RS2640B 55624250TF008 260950 COIL ADJUSTABLE MAIN CBA RS2640B 55624250X001 252832 CRYSTAL 75KHZ MAIN CBA RS2640B 55106010X002 NONSTK WIRE JUMPER MAIN CBA RS2640B 55079290X401 NONSTK WIRE JUMPER MAIN CBA RS2640B 55079290X701 260923 DISPLAY MAIN CBA RS2640B 55551110X885 267140 WCL UL1007 HOOK-UP MAIN CBA RS2640B 20925510Y001 245476 FILTER 10.7MHZ MAIN CBA RS2640B 20906450Y002 245476 FILTER 10.7MHZ MAIN CBA RS2640B 20906450Y701 231718 RESONATOR 4.194MHZ MAIN CBA RS2640B 20496690Y702 251563 FILTER 32.768KHZ MAIN CBA RS2640B 55093470
Page 11 of 11
Instrument Exploded View
Copyrighted Thomson Inc.
CD Mechanism Exploded View
�Copyrighted Thomson Inc.
N001
1 2
N706
1
2
3
4
5
6
7
8
9
P0271 2 3 4 5 6
P026
1
2
P0241 2
N0271 2 3 4 5 6
N0061 2 3
P0061 2 3
NJ501
1 2 3 4
N302
12
34
P702
1 2 3 4 5 6 7 8 9 N3011 2 3 4 5 6 7 8 9 10
N300
12
34
N5161 2 3
N705
1
2
3
4
5
6
7
N801A
1 2 3
P706
1
2
3
4
5
6
7
8
9
N702
1 2 3 4 5 6 7 8 9 P3011 2 3 4 5 6 7 8 9 10
P705
1
2
3
4
5
6
7
P5161 2 3
P701
1 2 3 4 5 6
N801B
1 2 3 4 5
N701
1 2 3 4 5 6
AM_ANT
- -
+ +
--
++
AUX_IN JACK
AM ANT JACK
M
CASSETTE BD
MAIN & POWER AMP BORADX'MER BOARD
BOARDHEADPHONE
KEY BOARD
CDM5
B DR
IVER
BOA
RD
MAINL R
Interconnect Diagram
Copyrighted Thomson Inc.
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
22
23
24
25
26
27
28
29
30
31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 46 47 48 49 50
51
52
53
54
55
56
57
58
59
60
61
62
63
64
65
66
67
68
69
70
71
72
73
74
75
76
77
78
79
80
81828384858687888990919293949596979899100
12
34
56
7
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
12
12
1
2
12
12
12
12
34
56
78
1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39
1
2
3
1
2
3
6
7
5
8
4
1
2
3
12
34
56
1
2
3
12
34
56
78
9
ATS SURROUNDRDS BASSAUXST
PROG
AM PMFM LW
MWINTRO1 DISCSREPEATALLSHUFFLEMIX
KHz
MHz
CD TUNER TAPE
10K10uF
10K
47uF 100uF
uPD780205GF
1UF
470uF
47uF
4u7F
100uH
KTC3198GR
KTC3875GR
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
KTC3203Y
KTC3198GR
KTC3198GR
33pF33pF
33pF
33pF4M19HZ
32768Hz
7.5K 47k
1.5k
2.7K
10K
82K1.2K 4.7K
4.7k3.3k
10K
22K
3.3k2.2k1.5k1.2k
10K 1.5k1.2k
4.7k
10K
8.2K
330
2K
1K
68K
22k
1K
22K
10K
12k
22K
22K
22K
22K
22K
47K
47K
22K
22K
22K
22K
1K
39K
39K
22K22K
100R
2.2k
10k
10k
100nF
100pF100pF
47NF
47nF
100nF 100nF
47nF
1nF
1nF
1nF
100nF
1nF
100nF
47N
100N
1nF1nF
4K7
4k7
1K
1K
1K
1K
1K
1K
1K
1K
1K
1K
1K
1K
10k
330
1K
1K
1K
10K
47K
100
1K
2K
100nF
ST24C01B1GP1U287R
10K
C701 C702
IC701
C713
C706
C730
C721AD716
L701
P705
SW715
SW718
SW717SW716
SW712SW711SW710SW709SW708
SW707SW706 SW704
SW702SW703
SW701
SW714
SW705
SW713
Q701
Q705
D704
D713
D712
D707
D708
D709
D711
D710
D703
D714
D715
D717
D718
D721
D730
D701
D702
Q702
Q704
Q703
C712C711
C714
C715Y701
Y702
R744 R780
R729
R728
R735
R745R759 R793
R737R736
R797
R741
R743R742R799R798
R790 R796R795
R706
R794
R792
R701
R791
R788
R739
R700
R783
R760
R708
R709
R769
R761
R771
R762
R764
R763
R765
R766
R767
R768
R770
R784
R413R
R413L
R414
LR4
14R
R702
R740
R714
R805
C705A
C726C725
C721
C707
C704 C705
C708
C790
C791
C792
C753
C793
C755
C750
C751
C414LC414R
R725
R705
R754
R753
R752
R748
R749
R750
R751
R755
R747
R746
R757
R756
R703
R786
R718
R717
R716
R707
R710
R704
R712
R726
P706
X701
NJ504
C430
IC702IR701
P701
P516
P702
R734
Power (Red)
10V 10V
10V
10V
10V
10V
1/2W6V2
1/2W6V2
50V50V
50V
50V
1/16W 1/16W
1/16W
1/16W
1/16W
1/16W1/16W 1/16W
1/16W1/16W
1/16W
1/16W
1/16W1/16W1/16W1/16W
1/16W 1/16W1/16W
1/16W
1/16W
1/16W
1/4W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W1/16W
1/16
1/16W
1/16W
1/16W
50V
50V50V
50V
50v
50V 50V
50V
50V
50V
50V
50V
50V
16V
1/16
1/16
50V50V
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
16V
1/16W
AUX IN
For EU version
DISC SKIPBASS
Display/Front Panel Schematic
Copyrighted Thomson Inc.
12
3
12
1
2
34
5
6
1
2
34
6
1
2
3 4
6
1
2
34
6
1
2
3 4
6
1
2
3
4
5
6
7
8
9
10
11
12 13 14 15 16 17 18 19 20 21 22
23
24
25
26
27
28
29
30
31
32
33
3435363738394041424344
C019
C020
C035
C028
C023
C046
C045
C047
C026
C003
C004
C036
C015
C009
C012
C041
C025
C021
C010
C013
C014
C060
C031
C030
C022
C011
RV00
1
R014 R013
R056
R047
R045
R046
R015
R012
R035
R011
R031
TF006
N002
TF001
R021
R097
R009
R008
R030
R036
R007
R034
R006
R017
R005
Q008
C034
C032
C033
C027
C024
C007
C099
C008
Y002
Y001
TF003
TP008
TP001
TP003
TP010
TP005
TP002
TP001G
TP006
TP007
TP004
TF007
TF005
Q009
TF008
GC0
18
GCV
001
G
CV00
2
IC001
X001
L003
L001
L004
L007
D001
D002
R010
C016
C062
C050
D003
C001
CA03
R057
R058
C029
TP012
TP011
TP009
D005
D004
JP02
C043
RFGND
SELE
CTIO
N
Tuner Schematic
Copyrighted Thomson Inc.
12
34
4 5
6
10 11
12
1617
18
78
9
1 2
3
13 14
15
12
34
12
34
56
78
910
1234567
8 9 10 11 12 13 14
PB REC
DECK 1REC/PLAYBACK
BIAS OSC
TP60 TP60G
L303L301
L302
N302
C309L
C301
C303
C309R
C302
C305R
C305L
C306R
C306L
SW1
SW1
SW1
SW1
SW1
SW1
R300
R301
R302
R304
R303RR302R
R305R
R302L
R303L
R305L
R305
C303R
C304
C304R
C303L C304L
C308R
C308L
C300C305
C306
N300
Q301
R316
RR301R R304R
R316
L
R301L
R304L
R306R
R315L
R315R
R307R
R307L
R306L
C301R
C302R
C301L C302L
R309
R307
R306
N301
R310
R308
Q302
-
+
-
+
AMP CH1
AMP CH2RIPPLE FILTER
ALC
IC30
0
Q303
KTC3203
KTA1271Y
KTC1815
AGND
REC-R
REC-L
7V
R/O
REC-S
L/O
M-GND
12V
TAPE_MUTE/STANDBY
470u220u
470u
2n250V
33nF50V
68nF50V
2n250V
6n8F50V
220pF25V
220pF25V
47nF50V
47nF50V
2201/4W
56K1/4W
47k1/4W
1201/4W
7R51/4W
10K1/4W
33K1/4W
10K1/4W
7R51/4W
33K 1/4W
22K1/4W
100uF50V
10uF50V
10uF50V
100uF50V
10uF50V
1uF50V
1uF50V
100uF10V
22uF50V
100uF10V
5.6K
1/4W12K
1/4W1K21/4W
5.6K
1/4W
12K1/4W
1K21/4W
1K1/4W
5.6K1/4W
5.6K1/4W
390K1/4W
390K1/4W1K
1/4W
1.8nF50V
100nF50V
1.8nF50V
100nF50V
220
1/4W
10k
1/4W
5.6K
1/4W
10K1/4W
10k
1/4W
M
Cassette Audio Schematic
Copyrighted Thomson Inc.
P008
1
2
3
4
5
6
7
8
P0041
2
D002
D001
C004
C002
C006R005
R004
R003
P003
1
2
3
4
5
6
R002
P005
1
2
3
4
5
6
7
8
9
P002
1
2
3
P006
1
2
3
N006
1
2
3
C005
D003 D004L001
PI002
2
1
3
4
PI005
2
1
3
4
PI006
2
1
3
4
PI001
2
1
3
4
P007
1
2
R001
JC001
JD001
IC001
1 2 3 4
5678
IC002
1 2 3 4
5678
P009
1
2
3
4
5
6
7
B. All Capacitor values are in F
MODULETCM
safety of this unit.
to maintain proper performances and
specified from replacement parts list
components. Replace only with those5. * and indicates critical safety taken in radio "on" position
4. Unless otherwise stated, all voltages
specified from replacement parts list
3. Replace transistors with type and volume control minimum
to ground under no signal conditions
2. Voltages are positive with respect
1/8W A. All resistor values are in ohms,1. Unless otherwise specified:
NOTES:
DRIVERMOTOR
DRIVERMOTOR
1
2
3
4
5
6
P008
7
8
9
-+
KEY DISPLAY BOARD
(CIRCLE)
CAROUSEL MOTOR PCBTO/FROM
TO/FROM
TO
FROM
SENSORS
DRAWER POSITION
MAIN BOARD
AMP BOARD
DRAWERMOTOR
M
100nF
100nF
10nF100
2R2
2R2
100
1000uF
1N4002 1N400239uH
RPI-574
RPI-574
RPI-574
RPI-574
FAN8082
FAN8082
DRAWER2
DRAWER1 BD
SLIDER POSITION
1/2W5V6
1/2W5V6
25V
25V
50V1/4W
1/4W
1/4W
1/4W
25V
+V1
PLAT-SW
GND
DISC-SW
CRSMTR2
CRSMTR1
SLIDER1
SLIDER2
DRWMTR1
DRWMTR2
CD-RESET
+5V
SCLK
GND
SDATA
+V1CC
CD-R
AGND
CD-L
CD-R
AGND
CD-L
+12V
GND
+5V
CD-RESET
SDATA
GND
SCLK
DRAWER-
DRAWER+
DRAW2
DRAW1
DISC-SW
PLAT-SW
PLATTER+
PLATTER-
SLIDER2
SLIDER1
KAT
ANO
COL
EMIT
KAT
ANO
COL
EMIT
KAT
ANO
COL
EMIT
KAT
ANO
COL
EMIT
VO2
VCTL VIN1
VIN2PVCCSVCC
GND VO1
VO2
VCTL VIN1
VIN2PVCCSVCC
GND VO1
Carousel Motor Drive Schematic - IC001/2 FAN8082
Copyrighted Thomson Inc.
1
2
1 2 3 4 5 6 7 8 9 10
1 2 3 4 5 6 7 8 9 10
1
2
3
4
5
6
1
2
3
4
5
6
7
8
9
12
31
23
12
3
2
1
3
4
2
1
3
4
2
1
3
4
2
1
3
4
12
12
34
56
78
12
34
56
7
DRAWER2
DRAWER1 BD
SLIDER POSITION
LB1641
LB1641
1N4002 1N4002
RPI-574
RPI-574
RPI-574
RPI-574/GP1S58V
/GP1S58V
P004
IC002
IC001
D002
D001
C004
C003
C002
C001
C006
R005
R004
R003
P003
R002
P005
P002
P006
N006
C005
D003 D004L001
PI002
PI005
PI006
PI001
P007
R001
JC001
JD001
P008
P009
GND
OUT1
P1 VZ IN1
IN2
VCC1
VCC2
P2 OUT2
GND
OUT1
P1 VZ IN1
IN2
VCC1
VCC2
P2 OUT2
5V6
5V6
100nF25V
22pF50V
100nF25V
22pF50V
10nF50V
100
2R2
2R2
100
1000uF25V
39uH
KAT
ANO
COL
EMIT
KAT
ANO
COL
EMIT
KAT
ANO
COL
EMIT
KAT
ANO
COL
EMIT
A. All resistor values are in ohms,
safety of this unit. to maintain proper performances and
5. * and indicates critical safety
4. Unless otherwise stated, all voltages
1/8W B. All Capacitor values are in ?F
specified from replacement parts list3. Replace transistors with type
specified from replacement parts list components. Replace only with those
taken in radio "on" position
and volume control minimum to ground under no signal conditions2. Voltages are positive with respect
1. Unless otherwise specified:
NOTES:
MODULETCM
-+
1
2
3
4
6
7
8
9
KEY
DISP
LAY
BOAR
D
(CIRCLE)
CAROUSEL MOTOR PCBTO/FROM
TO/F
ROM
TO
FROM
SENSORS
DRAWER POSITION
P008
5
MAIN BOARD
AMP BOARD
BA6209N /
BA6209N /
DRIVER
DRIVER
MOTOR
MOTOR
DRAWERMOTOR
M
PLAT_SW
PLAT_SW
DRWMTR1
CRSMTR2
DRAWER-
SLIDER1
SLIDER1
DISC_SW
DISC_SW
+V1
SDATA
SDATA
CRSMTR1
SCLK
SCLK
DRAWER+
PLATTER-
CD_RESET
CD_RESET
PLATTER+
+5V
AGND
AGND
CD_R
CD_R
CD_L
CD_L
DRWMTR2
+12V
+V1CC
DRW2
GND
GND
GND
GND
SLIDER2
SLIDER2DRW1
5V
+5V.
Carousel Mot. Drv. Schematic - IC001/2 BA6029/LB1641
Copyrighted Thomson Inc.
12
34
7
8
9
12
12
34
56
78
91
23
45
6
1 2 3 4 5 6 7 8 9 10 11 12 13 141516171819202122232425262728
1
2
3
1
2
3
12
34
56
78
910
1
2
3
12
34
4
5
6
TDA7
440D
KTC3203Y
KTC3875
KTC3875
KTC3875
KTC3875
1N4148
KTC3875
KTC3875
KTC3875
10K
10K
10K
10K
1K
1K
2u2F
50V
AGND
R_IN
4
LOUT
ROUT VS
CREF SDA
SCL
D-GN
D
TREB
LE(R
)
R_IN
2
TREB
LE(L
)
NC2
NC1
BOUT
(L)
BOUT
(R)
BIN(
R)
IN(R
)
MUXO
UT(R
)
IN(L
)
MUXO
UTL
L_IN
4
L_IN
3
L_IN
2
L_IN
1
R_IN
1
R_IN
3
BIN(
L)
2u2F
50V
2u2F
50V
2u2F
50V
7V5
47uF25V
220uF16V
560
5K6
5K6
56
5n6F
50V
100nF50V
5n6F
50V
150nF50V
100n
F50
V
150n
F50
V
2u2F
50V
2u2F50V
2u2F50V
2u2F
50V
2u2F
50V
47uF
25V
100uF 10V
2u2F
50V
47K
2u2F
50V
2u2F50V
6.5uH
100nF50V
6.5uH
6.5uH
100nF50V 2K2
2K2
470uF10V
100pF 50V
100pF 50V
4K7
471.8K
100uF10V
100nF50V
180
22uF
25V
10K
22
1k470K
47K
1uF10V
4K7
1uF10V
47K
330k
1k
22
22UF
10V
22uF25V
180
10K
100uF10V
1.8K
1/4W B. All Capacitor values are in uF
A. All resistor values are in ohms,
safety of this unit. to maintain proper performances and
5. * and indicates critical safety
4. Unless otherwise stated, all voltages
specified from replacement parts list3. Replace transistors with type
specified from replacement parts list components. Replace only with those
taken in radio "on" position
and volume control minimum to ground under no signal conditions2. Voltages are positive with respect
1. Unless otherwise specified:
NOTES:
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/2W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/16W
1/2W1/16W
1/4W
1/16W
1/16W
1/16W 1/16W
1/16W
1/16W
1/16W
1/16W1/16W
1/16W
1/4W
1/4W
1/16W
P601ANJ503
P101
R401L
R402L
R401R
R402R
R407
R408
N702
N701
C409
R
IC40
1
C409
L
C453
L
C402
L
P401
Q401
D402C410
C411
R401
R403R
R403L
R420
C404
R
C408R
C404
L
C407R
C408
LC4
07L
C453
R
C410L C410R
C402
R
C401
R
C420
C400
C401
L
R410
N516
P301
C400
L
C400
R
L603L
C601R
L602
L603R
C601L
NJ503P601
Q410R
R617L
R617R
C600
C403
C402
Q410L
R410R
Q603L
R600
R615L
C605L
C061
R616L
C604L
R411
Q602L
R613L
R612LR610L
R611L
C611L
R410LD401
C611R
R611R
R610RR612R
R613R
Q602R
C412
C604R
R616R
R412
C605R
R615R
Q603R
Q410
NJ503
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
AGND
FIL-
RECORD_R
RECORD_L
FIL+
AUX_L
TUNER_L
TAPE_L
6.8V
6.8V
CD_L
TAPE_R
+10V
+10V
+10V
D-GND
AUDIO_R
AUDIO_R
AUDIO_R
CLOCK-T
TUNER-PWR
CD_R
GND
ST-MONO
TUNER_R
AUX_R
H/P_IN
DATA-T
WR-EN
H/P_VCC
H/P_VCC
CD_SYNCHRO
CD_SYNCHRO
H/P_MUTE
SDATA
SDATA
SCLK
SCLK
TAPE_MUTE
TAPE_MUTE
AUDIO_L
AUDIO_L
AUDIO_L
-30V
Audio Switching/ Headphone Jack Schematic
Copyrighted Thomson Inc.
1
23
4
56
7
8
910
11
12
13
14
15
1
23
4
56
7
8
910
11
12
13
14
15
12
34
5
12
34
12
12
3
1
2
3
1 2
L
N
SEE NOTEWARNING
WARNINGSEE NOTE
SEE NOTEWARNING
WARNINGSEE NOTE
SEE NOTEWARNING
SEE NOTEWARNING
SEE NOTEWARNING
SEE NOTEWARNING
SEE NOTEWARNING
SEE NOTEWARNING
SEE NOTEWARNING
SEE NOTEWARNING
SEE NOTEWARNING
TDA7293
TDA7293
1N4001
KTC3875GR
KTC3875GR
1N4148
1N4148
1N5402
1N54021N5402
1N5402
1N4001
1N40011N4001
1N4001
1N4148
1N4148
1N4148
1N4148
1N4148
1N4148
KIA7812
1N4001
KTA1273
-POW
ER_S
UPPL
Y
AUDIO_R
FIL-
NEUTRAL
H/P_MUTE
AGND
AGND
AMP_MUTE
L
-30V
H/P_IN
R
LIVE
AUDIO_L
+POW
ER_S
UPPL
Y
FIL+
+10V
+10V
SHIELD_GND
L501L
L501R
IC501
IC502
N801
B
JP881
X885
D501
D514
R532
C806
R886 D821
D819
JW07
JW08
Q501
Q503
F503
F504
R502L
R512L
R512R
R510L
R510R
R502R
R507R
R507L
R885
R881 R888
R531
R530
C522L
C501R
C520
C518
C528C527
C526
C518R
C518L
C525
C531
C530
C521R
C521L
C501L
C522R
C524
C532
C529
C533 C505R
C507L
C507R
C505L
C519R
C519L
C502
R889
C535C534
C538
C537
C514
C513
C502L
C512
C502R
C503
C515C516
C509R
C509L
D503
NJ501
D501L
D507
D506D505
D508
D512D509D510
D511
D502L
D502R
D516
D513
D515
D501R
N501
N801A
R529
R525
R502
R501L
R501R
R512
R511
R503L
R503R
R510
R509
R503
R505
R504R506RR506L
C540
RF505
R505L
R505R
C807
D504
C805
IC503
JW05
JW04
JW3
JW2
JW1
D822
JW06
D820
X884
X883
N
L
C523
C539
Q502
L503L
L503R
L502R
L502L
PF01
0.5uH
0.5uH
STBY
MUTE
SGND
IN-
IN+
CLIP_DET
BUFFER_DRIVER
+VS
OUT
BOOT_LOADER
BOOTSTRAP
STBY-GND
-VS
-PWVS
+PWVS
STBY
MUTE
SGND
IN-
IN+
CLIP_DET
BUFFER_DRIVER
+VS
OUT
BOOT_LOADER
BOOTSTRAP
STBY-GND
-VS
-PWVS
+PWVS
1/2W5V1
1/2W>25V
1K5
1/16W
100uF50V
220 1/2W
1/2W
7.5V
5S_5A_125V
5S_5A_125V
33K1/16W
4R71/16W
4R71/16W
101/4W
101/4W
33K1/16W
100K1/16W
100K1/16W
10k1/4W
1/2W3M3
11/4W
4K71/2W
4K71/2W
1NF50V
5pF50V
100nF 63V
100nF63V
100nF 100V100nF 100V
100nF 100V
100nF16V
100nF16V
100nF 100V
100nF50V
100nF50V
330nF50V
330nF50V
5pF50V
1NF50V
100nF 63V
100nF50V
100nF 50V
100nF63V
1NF50V
470pF50V
470pF50V
1NF50V
100nF 16V
100nF 16V
100pF50V
11/4W
10uF50V
10uF50V
22uF25V
22uF25V
2200uF
25V
4700uF
50V
1uF50V
4700uF50V
1uF50V
47uF25V
22uF16V
22uF25V
47uF50V
47uF50V
10K1/16W
33K1/16W
4701/16W
33k1/16W
33k1/16W
6K81/16W
10K1/16W
3901/16W
3901/16W
1K 1/16W
101/4W
10K1/16W
10K1/16W
1K1/4W
22k1/16W
22k1/16W
100uF50V
0.27 1W
2K21/16W
2K21/16W
100nF50V
1/2W2V4
100uF50V
GNDOUT IN
1.3W27V
100nF
25V
100uF
50V
5uH
5uH
5uH
5uH
N/A
Audio Output/Power Supply Schematic
Copyrighted Thomson Inc.
