Upload
others
View
9
Download
0
Embed Size (px)
Citation preview
55S18W (E4) N. : WBEE1 DT1
Gearbox 6S-400OD
Drive VcbCabWheelbase
LEFT HAND DRIVE WBEE1IA1LST3050
LEFT HAND DRIVE WBEE1IB1LST3400
2 30/07/2007
55S18W (E4) N. : WBEE1 DT1
DIMENSIONS (mm) (55S18W4 LST)
34003050A Wheelbase
54324921B Overall length
900900C Front overhang
1132971D Rear overhang
20162016E Max cab width
16161616H Front axle to front of body
26342644K Overall height to top of cab, unladen
11091107L Frame height at end of frame, unladen
17001700M Front track
10701700N Rear track
50°50°Approach angle
30°32°Departure angle
3 30/07/2007
55S18W (E4) N. : WBEE1 DT1
Weights (kg) (BB55S18W4 LST)
34003050Wheelbase
55005500GVW EEC
24502450Plated weight on axle 1 EEC
37003700Plated weight on axle 2 EEC
29552985Max body & payload EEC
25452515Total vehicle kerbweight
17251715Total vehicle kerbweight 1
820800Total vehicle kerbweight 2
4 30/07/2007
55S18W (E4) N. : WBEE1 DT1
Engine F1CVGT ( F1C1764X4)
FRONTPosition
LONGITUDINALDirection of engine
DIESELCycle
TC+INTERCOOLER, VARIABLE GEOMETRYAspiration type
UNIJET COMMON RAIL - 16 VALVESInjection type
IN-LINE4No. of cylinders
DIESEL Fuel type
44 Stroke / 2 Stroke cycle
2998Total displacement cm³
/ 10495.8Bore / Stroke mm
176 HP130 kWMax power (1)
÷ 3000 rpm1250400 NmMax torque (2)
HIGH PRESSURE / COMMON RAIL (1600 bar)Injection pump type
EDCInjection pump governor type
WATERCooling system
Hydraulic steering pump
GLOW PLUGSCold starting type
EURO 4Emissions according regulations
Exhaust gas treatment: diesel particulate filter as standard
5 30/07/2007
55S18W (E4) N. : WBEE1 DT1
Fuelling (AB35SW)
1No. of tanks
PLASTICMaterial
90Total tank capacity l.
LEFT SIDEPosition on frame
Filter
Fuel filler on neck
Air intake (AC S4X4-I)
DRYFilter type
AT FRONT, UNDER BONNETAir intake
Clogged air filter sensor.
Cooling (AD S2002-I)
WATERCooling system
ELECTROMAGNETICFan type
Clutch 11'' (FB S2146-I)
SINGLE DRY PLATEType
PULL TYPEActuation
HYDRAULICRelease control
AUTOMATICAdjustment
GearboxZF - 6S-400OD (GB S6400)
SYNCHROMESHType
ENGINE FLANGEDInstallation
6+1No. of gears (… .+… ..reverse)
ALUMINIUMCasing material
Gear ratios
5.3731st
3.1542nd
2.0413rd
1.3654th
1.0005th
0.7916th
4.838Rev. 1st
6 30/07/2007
55S18W (E4) N. : WBEE1 DT1
Transfer box (HB 35S18W)
2 REDUCTIONSType
3Shafts no.
32%Torque distribution: front
68%Torque distribution: rear
PERMANENTAll wheel drive
Differential lock
ON ROADNormal Ratio: 1:1Low Ratio: 1:1.244
OFF ROADNormal Ratio: 1:3.115Low Ratio: 1:3.866
Total ratios: 24, in combination with gearbox ratios.
ON / OFF Road lever: selection only at speed = 0 km/h
Front driving axle (LB HS6.07 )
HS6.07Identification
RIGIDType
SINGLEReduction type
4.87Reduction ratio
Differential lock (as an option)
Rear drive axle (LB HS8.09 )
HS8.09Identification
RIGIDType
SINGLEReduction type
4.87Reduction ratio
Differential lock
Suspensions (NB 55SW4)
PARABOLIC + TORSION BARSFront driving axle
PARABOLIC + TORSION BARSRear drive axle
Main features
21Axle no.
43No. of main leaves spring
(*) Rear suspensions with rubber buffers
7 30/07/2007
55S18W (E4) N. : WBEE1 DT1
Shock absorber (PB S2000-I)
2Shock absorber no. (front)
2Shock absorber no. (rear)
HYDRAULIC TELESCOPICShock absorber type
Anti-roll bars (OB 35-50)
FRONT AND REAR AXLEPosition
TORSION BARType
Wheels (QB S2006-I)
DISCWheel type
STEELWheel material
Tyres (RT 0002-I)
9.5 R 17.5Tyre dimensions
129/127Load-index
L = 120 Km/h Speed index
409Rolling radius mm
Note: The 255/100 R 16 tyre (for off-road duties) is available as an option
Steering (KB S2000-I)
HYDRAULICType
420Steering wheel diameter (mm)
3No of parts in steering column
Chassis (mm) (JB S200W-I)
BOX TYPEFrame section
34003050Wheelbase
STEEL Fe490STEEL Fe490Side member material
5656Upper flange width
5656Lower flange width
144144Side member max. height
846846Frame width at front
962901Frame width at rear
Note:
in the section AA, the frame is "box type" 144x56x5 (partially open).In the section BB, the frame is "box type" 144x56x5 (completely closed), with a vertical reinforcement of 124x4
8 30/07/2007
55S18W (E4) N. : WBEE1 DT1
Brakes (SB55W)
ABS 5.3Antiskid system
COMBINED WITH PARKING BRAKEEmergency brake
HYDRAULICService brake
AXLE 2Parking brake axle(s)
EECBrake standards
2No. of circuits
Axle 2Axle 1Axle no.
DRUMDISCBrake type
2No. of cylinders
46Cylinder diameter
297Disk diameter (mm)
270 Drum diameter (mm)
80 Linings width (mm)
Electrics (VB35S12)
12Voltage V
14/110Alternator power V/A
1No. of batteries
12Battery voltage V
110Battery capacity Ah
2.3Starter motor power kW
Lighting (WB S2006-I)
2No. of headlights
HALOGENType of lamps
Front side marker lights
Reverse lights
Hazard lights
Number plate lights
Front fog lights
Rear fog light(s)
Side lights
Front direction indicators
Side direction indicators
Rear direction indicators
Additional lights prearrangement
9 30/07/2007
55S18W (E4) N. : WBEE1 DT1
Cab LST (YB35SW)
SEMI-FORWARD FIXEDCab type
STEEL PLATEMaterial
SIDE HUNGFront doors type
64°Front door(s) opening angle
Doorway lever
Glove compartment
COVERED WITH SYNTHETIC MATERIALCab floor
FULL ELECTRICALWindow operation (front)
2Sun visors no.
1Interior light
Monolithic execution
Plastic covering
LAMINATEDWindscreen type
ONE PIECE - CURVEDWindscreen
EECWindscreen according to standards:
2No. of windscreen wipers
3No. of windscreen wiper speeds
Side windows
Seat belts
4Rear view mirrors no.
MANUALMirror control
3No. of places
2No. of seats
HEIGHT, LONGITUDINAL AND BACK INCLINATIONDriver seat adjustment
DUALPassenger seat(s) type
4No. of fan speeds
MANUALHeating control
MANUALAir ventilation control
Lighter
10 30/07/2007
55S18W (E4) N. : WBEE1 DT1
Cab LST (YB35SW)
Remarks:
Storage compartments with bottle holder, defrost system for door windows, arm rests on the doors. Anti-corrosion protection includes full cataphoretic dipping with galvanized boxed sections and strategic use of zinc plated panels in vulnerable areas. Protective under seal for all under body cabin area, wheel housing and engine area. Steel bumper and side mouldings.
Passenger's seat:Fixed, 2 seats bench
Floor:Covered with rubber mats.
Interior equipment:Storage compartments, shelves in overhead console, shelves at floor level below seats, interior lights, 2 spotlights, loud-speakers, gearshift lever on dashboard.
Central console:Storage compartments, central panel, adjustable air vents, ash-trays, lighter, heating control, cooled compartment (with opt. air conditioning).
Exterior equipment:Close proximity mirror on passenger's side, steps on both sides, front bumper, mudguard, fog lights.Handles on both sides, handle on A-pillar, rear underrun protection, spare wheel on left side, rear lights crossbar
In cab equipment (TB35SW)
11 30/07/2007
55S18W (E4) N. : WBEE1 DT1
In cab equipment (TB35SW)
Indicator lamps, on cluster:
- Parking brake- Brakes failure- Directions indicators- Generic failure - Seat belts not fastened- Fog lights- High beams- Wing lights- External lights failure- Rear fog light(s)- Open doors- Fuel gauge - Service- Tachograph failure- Coolant temperature- EOBD- Engine preheating- Water in fuel filter- Clogged air filter- Clogged fuel filter
COMFORT LCD Display panel includes :odometer - clock - headlamp orientation - trip computer - service - "Follow me" - seat belts not fastened - speed limits exceeding.
Switches on central console Rear fog lights - Hazard lights
Switches on central console (upper)Central differential lock lamp - Central differential lock switch - Rear differential lock lamp - Rear differential lock - Front differential lock lamp (opt.) - Front differential lock switch (opt.) - ABS failure lamp (if present) - Differential locks failure lamp - ABS disconnection lamp (if present)
Multifunction stalks: (Left) direction - Wing / Highbeam / Lowerbeam - Headlamp flash - Horn - Front fog lights(right) Windscreen wiper with intermittent wipe.
Miscellaneous (XBS2000CAB)
EC NORMSRear underride protection
Jack
Front towing hitch
Exhaust pipe discharges towards the centre of the vehicle (between the sidemembers)
12 30/07/2007