1LTZ035 APE 2012 Type.pdf · Flywheel 整速轮 Oil Charge ... 1 0.75 0.5 35 2508 2035 1637 1301 1009 766 566 Hasil perhitungan ini 1 0.75 0.5 45 2206 1787 1434 1136 877 661 484 berdasarkan

333

DORIN S.p.A. has been producing open type compressorsince 1932.

These compressor are constructed with the highest qualitymaterials and are therefore suitable for working inparticularly hard conditions.

Compressor are designed to offer top performance andspecial care has been given to have smooth and silentoperation.

Compressors ranging between 2Q-2 and 51VS are lubricatedvia a sling disk. These models can rotate only in a specificrotational sense, clearly marked on the compressors.

Compressors ranging between 62VS and 90VS are lubricatedvia a gear oil pump. Those models can rotate in both senses.

All open type compressor manufactured by Dorin are subjectto approval according to directive 94/9/CE-ATEX.

IMPORTANT NOTE

ATEX approval is excluding all mechanical componentsincluding but not limited to drive belts, inherent cases, andall electric components, including but no limited to oil heaterand to oil heater and capacity regulation coils.

Therefore, ATEX approval shall be considered effective onlyfor compressors rated without any kind of accessory. Eachcompressor shows following ATEX marking:

II = group 2 machinery

3 = Category 3 (zone 2)

G = explosive atmosphere with gas, vapor or fog presence

c = protection type for non-electric equipment (constructivesafety)

IIB = gas group

*** = it is not possible to exactly determine the machinetemperature class (EN13463 14.2g) since surfacestemperature depends on the rating conditions and on theselected refrigerant.

Temperature class can anyway be identified considering thegiven application, caring about what mentioned in thefollowing application envelopes.

意大利都凌自 1932年以来，已生产开放式的压缩机。

这些压缩机均采用最优质的材料，因此能适合在

特别恶劣的条件下操作。

压缩机的设计提供最佳性能和特殊考虑到要有平

滑和安静的操作。

在 2Q-2和 51VS之间的压缩机润滑是采用索旋盘式的设计。这些型号的润滑只可以在一个特定的

旋转方向，压缩机上有清楚地标明。

在 62VS和 90VS之间的压缩机润滑是采用齿轮油泵。这些型号可以双重旋转润滑。

所有开放式压缩机由都凌制造，须经 94/9/CE-ATEX根据认证。

重要注意事项

ATEX认证不包括所有机械部件，包括但不局限于驱动皮带，固有的情况下，所有的电器元件，包

括但不局限于油加热器和容量调节线圈。

因此，ATEX认证批准应为只对压缩机的设定，不包括任何一种配件。每台压缩机都显示 ATEX标志：

II=第 2组别机械

3 =第 3类别（区类 2）

G =有气体、蒸气或雾气存在的爆炸性环境

C =非电气设备的保护类型（建设性的安全）

IIB=气体组

*** =是不能准确地确定的机体温度等级（EN13463 14.2克），因为表面温度取决于额定值条件和所选择的制冷剂。

温度等级反正可以考虑地用于所特定的机组应

用，以上所提到的应用程序都跟随压缩机的说明

书信封里。

3

5

Model型号

Cyl.汽缸

数量

Bore钻孔

Stroke冲程

SweptVolume汽缸容积

Suction吸阀

Discharge卸阀

Flywheel整速轮

OilCharge注油量

Weight重量

r.p.m.每分钟转数

Power Input能量吸收

no。 [mm] [mm] [cm³] SL mm] DL [mm] [mm] * [kg] [kg] ** min max HP

2Q2 2 38 12 27.2 10s 10s 132-1Z 0.4 11 500 1500 1/3 – 22Q3 2 38 15 34.0 10s 10s 132-1Z 0.4 11 500 1500 1/3 – 22Q4 2 38 19 43.1 12s 12s 132-1A 0.4 11 500 1500 0.5 – 42Q5 2 38 24 54.4 12s 12s 132-1A 0.4 11 500 1500 0.5 – 5

1HVS 2 45 24 76 5/8” – 16 1/2” – 12 160-2A 0.5 17 500 1450 0.75 – 42GVS 2 60 30 170 3/4” – 18 5/8” – 16 160-2A 1.0 22 500 1450 2. – 7.53LVS 2 61 60 351 28s 3/4” – 18 270-3A 1.5 38 500 1300 4 -15

41VSR 2 74 65 560 28s 22s 303-3B 3.0 78 600 1300 5.5 - 2041VSM/3B 2 74 65 560 35s 28s 303-3B 3.0 78 600 1300 5.5 – 2041VSM/4B 2 74 65 560 35s 28s 303-4B 3.0 82 600 1300 5.5 – 20

51VSR 2 88 78 949 35s 28s 335-4B 4.0 118 600 1300 10 – 3051VSM 2 88 78 949 42s 35s 335-4B 4.0 118 600 1300 10 – 30

62/63 VS/4B 4 78 65 1245 42s 28s 310-4B 5.5 156 750 1750 15 – 5062/63 VS/6B 4 78 65 1245 42s 28s 310-6B 5.5 156 750 1750 15 – 5067/68 VS/6B 4 84 65 1440 54s 35s 310-6B 5.5 156 750 1750 15 – 75

80/81 VS 6 78 65 1865 54s 42s 310-6SPB 6.5 203 750 1750 15 – 9090VS 6 84 65 2160 54s 42s 310-6SPB 6.5 203 750 1750 15 – 90

* Belt types /皮带型号

** Gross weight with flywheel /全部重量加整速轮

FWFlywheel整速轮

CHCrankcase Heater曲轴箱加热器

BFHead Fan风机

WHWater Cooled Head水冷缸头

CRCapacity Control制冷量控制系统

USUnloaded Start卸载启动

ODPSOil Differential Pressure Switch油压差开关

Model FW CH BF WH CR US ODPS2Q A

1HVS A A2GVS A A3LVS A A A

41VSR A A A A41VSM/3B A A A A41VSM/4B A A A A

51VSR A A A A51VSM A A A A

62/63 VS/4B A A A A A A A62/63 VS/6B A A A A A A A67/68 VS/6B A A A A A A A

80/81 VS A A A A A A A90VS A A A A A A A

A Optional Accessories /任选附件

Q[W]

B[cm³] C S B [°C] +10 +5 0 -5 -10 -15 -20

0.5 0.33 0.33 35 1099 891 717 570 442 335 2480.5 0.33 0.33 45 967 783 628 498 384 290 212

0.75 0.5 0.33 55 834 675 540 426 327 245 177 ________________________

0.75 0.5 0.5 35 1371 1114 897 713 553 419 3100.75 0.5 0.5 45 1208 979 785 622 480 362 265 ▪ Performance data are based on0.75 0.75 0.5 55 1043 843 675 533 409 306 222 European Standard EN129000.75 0.5 0.5 35 1648 1337 1076 855 663 503 372 ▪ Suction gas temperature = 20°C0.75 0.5 0.5 45 1450 1174 942 747 576 435 318 for R134a, R404A, R22 (5K suction

1 0.75 0.5 55 1251 1012 810 639 491 367 266 gas superheat for R717)0.75 0.5 0.5 35 1992 1616 1300 1034 801 608 449 ▪ Liquid subcooling = 0 K0.75 0.5 0.5 45 1752 1419 1139 902 696 525 385 ▪ * Recommended Power

1 0.75 0.5 55 1512 1223 979 772 593 444 322 ________________________

0.75 0.5 0.33 35 1384 1123 903 718 557 422 3120.75 0.5 0.33 45 1217 986 791 627 484 365 267 ▪按照欧标 EN12900测试数据0.75 0.5 0.33 55 1051 849 680 537 412 308 224 ▪吸气温度 = 20°C用于 R134a,0.75 0.75 0.5 35 1730 1403 1129 898 696 528 390 R404A, R22 (5 K吸气过热用0.75 0.75 0.5 45 1521 1232 989 784 605 456 334 于 R717)0.75 0.75 0.5 55 1313 1062 850 671 515 385 279 ▪液体附加冷却 = 0 K

1 0.75 0.5 35 2075 1684 1355 1077 835 634 468 ▪ *建议能量1 0.75 0.5 45 1826 1479 1187 940 726 547 401 ________________________

1 0.75 0.5 55 1576 1274 1020 805 618 463 3351 0.75 0.5 35 2508 2035 1637 1301 1009 766 566 ▪ Hasil perhitungan ini1 0.75 0.5 45 2206 1787 1434 1136 877 661 484 berdasarkan pada standard1 0.75 0.5 55 1904 1540 1232 973 747 559 405 eropa EN12900

0.75 0.5 0.5 35 1750 1420 1142 908 704 534 395 ▪ Suction gas temperature = 20°C1 0.75 0.5 45 1539 1247 1001 793 612 461 338 for R134a, R404A, R22 (5 K suction1 0.75 0.5 55 1329 1074 860 679 521 390 283 gas superheat for R717)

0.75 0.75 0.75 35 2187 1775 1428 1135 880 668 493 ▪ Liquid subcooling = 0 K1.5 0.75 0.75 45 1924 1558 1251 991 765 577 422 ▪ * Disarankan untuk kapasitas1.5 0.75 0.75 55 1661 1343 1075 848 651 488 353 ________________________

1 0.75 0.75 35 2625 2130 1713 1362 1056 801 5922Q-4

800

43.1

1000

1200

2Q-3

800

34.0

1000

1200

1450

2Q-2

800

27.2

1000

1200

1450

Refrigerating Capacity /制冷量 / Kapasitas Pendinginan

Evaporating Temperature /蒸发温度 / Suhu Pada Evaporator [°C]

C S

Model型号

Jenis

r.p.m.每分钟

转数

KecepatanMotor


KapasitasCylinder

HP-CV-PS *Power to install

Cond. Temp冷凝温度

Suhu PadaCondenser

/ Keunggulan Yang Dicatat

6

1 0.75 0.75 35 2625 2130 1713 1362 1056 801 5921.5 1 0.75 45 2309 1870 1501 1189 918 692 5071.5 1 0.75 55 1993 1612 1290 1018 782 585 4241 0.75 0.75 35 3172 2573 2070 1646 1276 968 715

1.5 1 0.75 45 2790 2260 1814 1437 1109 836 6131.5 1 0.75 55 2408 1947 1559 1230 944 707 5121 0.75 0.5 35 2198 1783 1435 1140 884 671 4961 0.75 0.5 45 1933 1566 1257 996 768 579 424

1.5 1 0.75 55 1669 1349 1080 852 654 490 3551.5 0.75 0.75 35 2747 2229 1793 1426 1105 839 6191.5 0.75 0.75 45 2416 1957 1571 1244 961 724 5311.5 1.5 0.75 55 2086 1686 1350 1065 818 612 4441.5 1 0.75 35 3296 2674 2152 1711 1326 1006 7431.5 1 0.75 45 2900 2348 1885 1493 1153 869 6372 1.5 1 55 2503 2024 1620 1279 982 735 532

1.5 1 0.75 35 3983 3232 2600 2067 1603 1216 8981.5 1 1 45 3504 2838 2278 1804 1393 1050 7692 1.5 1 55 3024 2445 1957 1545 1186 888 643

1.5 1.5 0.75 35 3093 2509 2019 1605 1245 944 6971.5 1 1 45 2721 2204 1769 1401 1082 815 5972 1 1 55 2348 1899 1520 1200 921 689 500

1.5 1.5 0.75 35 3866 3137 2524 2006 1556 1180 8721.5 1.5 1.5 45 3401 2754 2211 1751 1352 1019 7473 1.5 1.45 55 2936 2374 1900 1500 1151 862 6252 2 1 35 4639 3764 3029 2408 1867 1416 10462 1.5 1.5 45 4081 3305 2653 2102 1622 1223 8963 1.5 1.5 55 3523 2848 2280 1799 1381 1034 7492 2 1 35 5606 4548 3659 2909 2256 1711 12642 1.5 1.5 45 4931 3994 3206 2540 1960 1478 10833 1.5 1.5 55 4257 3442 2755 2174 1669 1249 9063 2 2 35 6553 5317 4278 3401 2637 2001 14784 3 2 45 5764 4669 3747 2969 2292 1728 12664 3 2 55 4976 4023 3220 2542 1951 1461 10593 3 3 35 8191 6646 5347 4251 3296 2501 1847 www.tongkian.sg4 3 3 45 7205 5836 4684 3711 2864 2160 15824 3 3 55 6220 5029 4026 3177 2439 1826 13234 3 3 35 9830 7975 6417 5101 3955 3001 2216

5.5 4 3 45 8646 7003 5621 4453 3437 2592 18985.5 4 3 55 7464 6035 4831 3813 2927 2191 15884 3 3 35 11877 9636 7753 6164 4779 3626 2678

5.5 4 3 45 10448 8462 6792 5381 4153 3132 22945.5 4 3 55 9019 7292 5837 4607 3537 2647 1919

2GVS

800

170

1000

1200

1450

1HVS

800

76

1000

1200

1450

2Q-5

800

54.4

1000

1200

1450

2Q-4 43.1

1200

1450

5.5 4 3 55 9019 7292 5837 4607 3537 2647 1919

2GVS 170

1450

6

Q[W]

B[cm³] C S B [°C] +10 +5 0 -5 -10 -15 -20

7.5 5.5 4 35 13469 11055 8832 6974 5429 4120 30457.5 5.5 4 45 11855 9709 7732 6080 4705 3543 259010 5.5 4 55 10256 8380 6651 5204 4001 2985 2153 ________________________

7.5 5.5 4 35 16837 13819 11040 8718 6786 5150 38067.5 5.5 4 45 14818 12137 9666 7600 5881 4429 3237 ▪ Performance data are based on15 5.5 4 55 12820 10475 8313 6505 5001 3731 2691 European Standard EN12900- 7.5 5.5 35 - - - 10462 8143 6180 4567 ▪ Suction gas temperature = 20°C- 7.5 5.5 45 - - - 9120 7058 5315 3884 for R134a, R404A, R22 (5K suction- 7.5 5.5 55 - - - 7806 6002 4477 3229 gas superheat for R717)

10 7.5 5.5 35 22628 18347 14773 11679 9095 6918 5121 ▪ Liquid subcooling = 0 K10 10 7.5 45 19872 16077 12904 10157 7862 5931 4338 ▪ * Recommended Power15 10 7.5 55 17137 13831 11062 8662 6657 4970 3582 ________________________

15 7.5 5.5 35 28285 22933 18467 14599 11369 8648 640115 15 7.5 45 24840 20096 16131 12696 9828 7413 5422 ▪按照欧标 EN12900测试数据15 15 7.5 55 21421 17289 13828 10828 8321 6212 4477 ▪吸气温度 = 20°C用于 R134a,15 10 7.5 35 33943 27520 22160 17518 13642 10377 7682 R404A, R22 (5 K吸气过热用15 15 10 45 29808 24115 19357 15235 11793 8896 6507 于 R717)20 15 10 55 25705 20746 16593 12994 9986 7455 5372 ▪液体附加冷却 = 0 K15 15 10 35 38543 31457 25363 19959 15572 11865 8801 ▪ *建议能量20 10 7.5 45 34207 27829 22342 17485 13544 10224 7489 ________________________

20 10 7.5 55 29885 24249 19398 15108 11628 8701 629820 15 15 35 47654 38892 31358 24677 19253 14670 10881 ▪ Hasil perhitungan ini25 15 10 45 42293 34406 27623 21618 16746 12640 9259 berdasarkan pada standard25 15 10 55 36949 29981 23983 18679 14676 10758 7786 eropa EN1290025 20 15 35 58166 47471 38275 30120 23500 17906 13281 ▪ Suction gas temperature = 20°C25 15 15 45 51622 41996 33716 26387 20439 15429 11301 for R134a, R404A, R22 (5 K suction25 15 15 55 45100 36594 29274 22800 17547 13131 9504 gas superheat for R717)25 15 15 35 57672 46940 37939 29909 23215 17570 13017 ▪ Liquid subcooling = 0 K30 20 15 45 51041 41431 33362 26168 20175 15131 11069 ▪ * Disarankan untuk kapasitas30 20 15 55 44472 35999 28872 22522 17231 12786 9211 ________________________

25 20 15 35 70393 57294 46308 36506 28336 21446 1588862VS/4B62VS/6B63VS/4B63VS/6B

1000

1245

1200

41VSR41VSM/3B41VSM/4B

800

5601000

1200

51VSR51VSM

800

9491000

1200

3LVS

800

3511000

1200



C S

Model型号

Jenis

r.p.m.每分钟

转数

KecepatanMotor


KapasitasCylinder



Suhu PadaCondenser


7

25 20 15 35 70393 57294 46308 36506 28336 21446 1588840 25 20 45 62300 50571 40721 31941 24625 18468 1351040 25 20 55 54282 43941 35241 27490 21032 15606 1124330 20 15 35 84811 69029 55793 43984 34140 25838 1914240 25 20 45 75061 60928 49061 38483 29669 22251 1627740 25 20 55 65400 52940 42459 33121 25340 18802 13545- 25 20 35 - - - 53220 41309 31264 23162- 40 25 45 - - - 46564 35900 26924 19696- 40 25 55 - - - 40076 30661 22751 16390

30 20 15 35 70031 57419 45984 36346 28310 21526 1591130 25 15 45 62153 50797 40508 31842 24623 18548 1353940 25 15 55 54300 44263 35171 27512 21138 15786 1138640 25 20 35 85479 70085 56128 44364 34554 26275 1942140 25 20 45 75863 62002 49443 38865 30055 22640 1652550 30 20 55 66278 54027 42929 33581 25801 19269 1389840 25 20 35 102987 84440 67624 53451 41632 31657 2339840 30 20 45 91401 74701 59570 46826 36211 27277 1991050 30 20 55 79853 65093 51722 40459 31086 23215 1674450 40 25 35 124614 102172 81825 64675 50375 38304 2831250 40 25 45 110596 90388 72080 56659 43815 33005 2409175 40 25 55 96622 78762 62583 48956 37614 28090 2026140 25 15 35 91926 75342 60309 47635 37068 28151 2076540 30 20 45 81709 68808 53309 41935 32465 24495 1791850 30 20 55 71561 58416 46505 36471 28121 21109 1534050 25 20 35 110311 90410 72370 57162 44482 33781 2491850 40 25 45 98051 80170 63971 50323 38958 29394 2150250 40 20 55 85873 70099 55806 43765 33746 25331 1840750 30 25 35 133292 109245 87447 69071 53749 40818 3010950 40 25 45 118478 96872 77298 60806 47074 35517 2598160 40 25 55 103763 84703 67432 52882 40776 30608 22242- 40 30 35 - - - 83362 64870 49263 36338- 50 30 45 - - - 73387 56814 42866 31357- 50 40 55 - - - 63824 49212 36941 26844

40 30 25 35 129064 105780 84673 66880 52044 39523 29154 www.tongkian.sg40 40 25 45 114720 93799 74846 58877 45581 34391 2515750 40 25 55 100471 82016 65293 51205 39482 29637 2153750 40 30 35 155952 127817 102314 80813 62887 47757 3522750 40 30 45 138620 113340 90439 71143 55077 41555 3039860 50 30 55 121403 99102 78895 61873 47708 35811 26024- 50 40 35 - - - 97533 75898 57638 42516- 50 40 45 - - - 85863 66472 50153 36687- 60 40 55 - - - 74674 57579 43220 31408

90VS

1200

21601450

1750

80VS81VS

1000

1865

1200

1450

1750

67VS/6B68VS/6B

1000

1440

1200

1450

1750

62VS/4B62VS/6B63VS/4B63VS/6B

1245

1200

1450

1750

- 60 40 55 - - - 74674 57579 43220 31408

90VS 2160

1750

7

Q[W]

[cm³] C S B [°C] +5 0 -5 -10 -15 -20 -25 -30 -35 -400.75 0.75 0.5 30 1393 1168 1021 841 699 574 427 353 303 2210.75 0.75 0.5 40 1187 1002 862 708 580 471 342 272 183 132

1 1 0.75 50 966 823 702 581 477 385 279 228 156 96 ________________________

0.75 0.75 0.75 30 1741 1460 1276 1051 873 717 533 441 378 2761 1 1 40 1484 1253 1077 885 725 588 428 340 229 165 ▪ Performance data are based on

1.5 1.5 1 50 1207 1028 878 726 597 481 349 284 195 119 European Standard EN129001.5 1.5 1.5 30 2087 1750 1530 1259 1047 860 639 529 454 331 ▪ Suction gas temperature = 20°C1.5 1.5 1.5 40 1779 1501 1291 1060 869 705 512 407 275 198 for R134a, R404A, R22 (5K suction2 2 1.5 50 1447 1232 1052 870 715 576 418 341 233 143 gas superheat for R717)2 2 2 30 2524 2116 1850 1523 1266 1039 773 639 549 400 ▪ Liquid subcooling = 0 K2 2 2 40 2151 1815 1561 1282 1051 853 620 493 332 239 ▪ * Recommended Power2 2 2 50 1749 1490 1272 1052 864 697 505 412 282 173 ________________________

0.75 0.75 0.5 30 1754 1470 1286 1058 880 722 537 444 381 2780.75 0.75 0.5 40 1495 1262 1085 891 730 593 431 342 231 166 ▪按照欧标 EN12900测试数据

1 1 0.75 50 1216 1036 884 731 601 484 351 287 196 120 ▪吸气温度 = 20°C用于 R134a,0.75 0.75 0.75 30 2193 1838 1607 1323 1100 903 672 556 477 348 R404A, R22 (5 K吸气过热用

1 1 1 40 1869 1577 1357 1114 913 741 538 428 289 208 于 R717)1.5 1.5 1 50 1520 1295 1105 914 751 606 439 358 245 150 ▪液体附加冷却 = 0 K1.5 1.5 1.5 30 2628 2203 1926 1586 1318 1082 805 666 571 417 ▪ *建议能量1.5 1.5 1.5 40 2240 1890 1626 1335 1094 888 645 513 346 249 ________________________

2 2 1.5 50 1822 1552 1325 1095 900 726 526 429 294 1802 2 2 30 3178 2664 2329 1917 1594 1309 973 805 691 504 ▪ Hasil perhitungan ini2 2 2 40 2709 2286 1966 1614 1323 1074 780 620 419 301 berdasarkan pada standard3 3 2 50 2203 1876 1602 1324 1089 878 636 519 355 218 eropa EN129001 1 0.75 30 2217 1859 1625 1338 1112 913 679 562 482 352 ▪ Suction gas temperature = 20°C

1.5 1 1 40 1890 1595 1372 1126 923 749 544 433 292 210 for R134a, R404A, R22 (5 K suction1.5 1.5 1 50 1537 1309 1118 924 759 612 444 362 248 152 gas superheat for R717)1.5 1.5 1 30 2772 2323 2031 1672 1390 1141 849 702 602 440 ▪ Liquid subcooling = 0 K2 1.5 1 40 2362 1993 1715 1408 1154 936 680 541 365 263 ▪ * Disarankan untuk kapasitas2 2 1.5 50 1921 1636 1397 1155 949 765 555 453 310 190 ________________________

2 2 1.5 30 3322 2784 2435 2004 1666 1368 1018 842 722 527



C S B

Model型号

Jenis

r.p.m.每分钟

转数

KecepatanMotor


KapasitasCylinder



Suhu PadaCondenser

2Q-2

800

27.2

1000

1200

1450

2Q-3

800

34.0

1000

1200

1450

2Q-4

800

43.1

1000

1200


8

2 2 1.5 30 3322 2784 2435 2004 1666 1368 1018 842 722 5273 2 1.5 40 2831 2389 2055 1687 1383 1122 816 648 438 3153 3 2 50 2303 1961 1675 1384 1138 917 665 543 371 2283 3 2 30 4017 3367 2944 2423 2015 1654 1230 1018 873 6374 3 2 40 3424 2889 2485 2040 1672 1357 986 784 529 3804 4 3 50 2784 2372 2025 1674 1376 1109 804 656 449 275

1.5 1.5 1 30 2786 2336 2042 1681 1398 1148 853 706 606 4422 1.5 1 40 2375 2004 1724 1415 1160 941 684 544 367 2642 2 1.5 50 1931 1645 1405 1161 954 770 558 455 311 1912 2 1.5 30 3483 2919 2553 2101 147 1434 1067 883 757 5533 2 1.5 40 2969 2505 2155 1769 1450 1177 855 680 459 3303 3 2 50 2414 2056 1756 1451 1193 962 697 569 389 2393 3 2 30 4174 3499 3059 2518 2094 1719 1279 1058 907 6624 3 2 40 3558 3002 2583 2120 1738 1410 1025 815 550 3954 4 3 50 2893 2465 2104 1739 1430 1153 836 682 467 2864 4 3 30 5048 4231 3699 3045 2532 2079 1546 1279 1097 8015 4 3 40 4302 3630 3123 2564 2101 1705 1239 985 665 4785 5 4 50 3499 2980 2545 2103 1729 1394 1011 824 564 346

1.5 1.5 1.5 30 3924 3289 2876 2368 1968 1616 1202 994 853 6232 2 1.5 40 3345 2823 2428 1993 1633 1326 963 766 517 3722 2 2 50 2720 2317 1978 1635 1344 1084 786 641 439 2692 2 2 30 4905 4112 3595 2960 2460 2020 1503 1243 1066 7783 3 2 40 4181 3528 3035 2492 2042 1657 1204 957 646 4653 3 2 50 3400 2896 2473 2044 1680 1355 982 801 548 3363 3 3 30 5879 4928 4309 3547 2949 2421 1801 1490 1278 9334 4 3 40 5011 4229 3637 2986 2447 1986 1443 1147 774 5574 4 3 50 4075 3471 2964 2450 2014 1624 1177 960 657 4034 4 4 30 7109 5959 5210 4289 3566 2928 2178 1801 1545 11285 4 4 40 6060 5113 4398 3611 2959 2402 1745 1387 936 6735 5 5 50 4928 4197 3584 2962 2435 1963 1424 1161 795 4874 3 3 30 8744 7329 6408 5275 4386 3601 2678 2216 1900 13874 3 2.5 40 7453 6289 5410 4441 3640 2954 2147 1706 1152 8284 3 2.5 50 6061 5162 4408 3644 2995 2415 1751 1428 977 5994 4 4 30 10934 9165 8013 6597 5484 4503 3349 2770 2376 1735 www.tongkian.sg4 4 3 40 9319 7864 6764 5554 4551 3694 2684 2134 1440 10364 4 3 50 7579 6455 5512 4556 3745 3020 2190 1786 1222 750

5.5 5.5 4 30 13124 11001 9618 7918 6583 5405 4020 3325 2852 20827.5 5.5 4 40 11186 9439 8119 6666 5463 4434 3222 2561 1728 12437.5 5.5 4 50 9097 7748 6616 5469 4495 3624 2628 2144 1467 9007.5 5.5 4 30 15869 13302 11630 9574 7960 6536 4861 4021 3449 25187.5 7.5 5.5 40 13526 11414 9818 8060 6605 5361 3896 3097 2090 1503

2Q-4 43.1

1200

1450

2Q-5

800

54.4

1000

1200

1450

1HVS

800

76

1000

1200

1450

2GVS

800

170

1000

1200

1450 7.5 7.5 5.5 40 13526 11414 9818 8060 6605 5361 3896 3097 2090 15037.5 7.5 5.5 50 10999 9369 8000 6613 5436 4383 3178 2592 1774 1088

2GVS 170

1450

8

Q[W]

[cm³] C S B [°C] +5 0 -5 -10 -15 -20 -25 -30 -35 -405.5 5.5 4 30 19153 16101 13145 10685 8538 6897 5478 4195 3183 24277.5 5.5 4 40 15650 13215 10739 8765 6949 5441 4248 3268 2518 1936

- 7.5 5.5 50 - - - - - 4210 3446 2410 1694 1196 ________________________

7.5 7.5 5 30 23948 20133 16436 13360 10676 8624 6849 5245 3980 303510 7.5 5 40 19568 16524 13428 10960 8689 6804 5312 4086 3149 2421 ▪ Performance data are based on- 10 7.5 50 - - - - - 5264 4309 3013 2118 1495 European Standard EN12900

10 7.5 7.5 30 33727 28354 23148 18816 15036 12145 9646 7387 5605 4275 ▪ Suction gas temperature = 20°C15 10 7.5 40 27559 23271 18911 15435 12238 9582 7481 5755 4435 3409 for R134a, R404A, R22 (5K suction- - 7.5 50 - - - - - 7414 6069 4243 2983 2105 gas superheat for R717)

10 10 7.5 30 31142 26181 21374 17374 13883 11214 8907 6821 5175 3947 ▪ Liquid subcooling = 0 K15 15 10 40 25447 21487 17462 14253 11300 8847 6908 5314 4095 3148 ▪ * Recommended Power- - 15 50 - - - - - 6846 5604 3918 2754 1944 ________________________

15 15 10 30 38979 32471 26622 21589 17379 13788 13238 10639 6474 453125 15 10 40 33345 27151 22127 17963 14437 10879 9000 6761 5076 3834 ▪按照欧标 EN12900测试数据15 15 15 50 25917 21996 17732 14552 11599 8779 7121 4943 3632 2796 ▪吸气温度 = 20°C用于 R134a,15 15 15 30 46793 38981 31959 25917 20864 16552 15892 12772 7772 5439 R404A, R22 (5 K吸气过热用20 20 15 40 40031 32595 26563 21565 17331 13061 10804 8117 6094 4603 于 R717)20 20 20 50 31113 26406 21287 17469 13925 10539 8549 5934 4360 3356 ▪液体附加冷却 = 0 K20 20 20 30 50023 41917 34466 27736 22699 17885 14689 11346 8495 5989 ▪ *建议能量25 20 20 40 43263 34712 28182 22734 18634 13950 11728 8634 6385 4726 ________________________

25 25 20 50 33450 28217 22607 18346 14784 11085 9090 6727 4962 361920 20 20 30 62247 52160 42889 34514 28246 22255 18279 14119 10571 7453 ▪ Hasil perhitungan ini25 20 20 40 53835 43195 35069 28289 23187 17359 14594 10744 7946 5881 berdasarkan pada standard25 25 20 50 41624 35113 28132 22829 18397 13794 11311 8371 6174 4504 eropa EN1290025 25 25 30 74997 62844 51674 41583 34031 26813 22023 17011 12736 8979 ▪ Suction gas temperature = 20°C30 25 25 40 64862 52043 42251 34084 27937 20914 17583 12945 9573 7086 for R134a, R404A, R22 (5 K suction30 30 25 50 50150 42304 33894 27505 22165 16619 13628 10086 7439 5426 gas superheat for R717)30 30 25 30 99949 83905 68589 55938 45167 35867 29649 22835 17322 12791 ▪ Liquid subcooling = 0 K40 30 25 40 86295 69329 56458 46309 37019 29046 23643 17976 13792 10731 ▪ * Disarankan untuk kapasitas50 50 25 50 66840 56784 45793 37694 28841 23016 16864 14485 11119 - ________________________

40 30 25 30 120857 101457 82937 67640 54616 43370 35851 27612 20945 1546740 40 25 40 104347 83832 68269 55997 44763 35123 28589 21736 16677 12976


Suhu PadaCondenser



C S B

1000

Model型号

Jenis

r.p.m.每分钟

转数

KecepatanMotor


KapasitasCylinder



1245

3LVS

800

351

1000

1200

1300


1000

560

1200

51VSR51VSM

800

949

1200

1200

1450


9

40 40 25 40 104347 83832 68269 55997 44763 35123 28589 21736 16677 1297650 50 30 50 80822 68662 55372 45579 34875 27831 20391 17515 13445 -50 40 40 30 145874 122459 100105 81641 65921 52348 43272 33328 25281 18669- 50 30 40 - - - 67588 54029 42393 34507 26235 20129 15662- - - 50 - - - - - - - - - -

50 50 40 30 143698 124521 98994 81129 64974 51864 42187 32193 24193 1733760 50 40 40 123608 99914 80760 66597 52822 41564 33294 24831 18585 1399075 60 40 50 95121 81137 64930 53439 40440 32186 26086 17333 11650 -60 60 50 30 173444 146676 119486 97923 78423 62600 50920 38857 29201 2092675 60 50 40 149195 120596 97477 80383 63756 50168 40186 29971 22432 16886- - 60 50 - - - - - - 31486 20921 14062 -

60 50 50 30 181369 153527 125009 102403 82218 65443 53662 40789 30543 2192075 60 50 40 155833 125882 101992 83929 66417 52247 41903 31311 23415 1751775 60 50 50 119578 101933 81610 67186 50697 40195 32596 24078 17692 1281375 60 60 30 218912 185307 150886 123600 99237 78990 64770 49232 36865 26457- 75 60 40 - - - 101302 80166 63062 50577 37792 28262 21143- 75 60 50 - - - 81094 61192 48516 39343 29062 21354 15465

75 70 50 30 204706 173282 141094 115579 92798 73864 60567 46038 34473 2474190 70 60 40 175885 142080 115116 94728 74964 58969 47295 35340 26428 19771

100 80 60 50 134965 115050 92112 75832 57221 45367 36790 27176 19969 14462 www.tongkian.sg90 80 60 30 247081 209151 170301 139504 1E+05 89154 73104 55567 41609 29862- 85 70 40 - - - 114337 90481 71176 57085 42655 31899 23864- 90 70 50 - - - 91529 69066 54758 44406 32802 24102 17455


1245

90VS

1450

2160

1750

1450

1750

80VS 81VS

1450

1865

1750

67VS/6B68VS/6B

1450

1440

1750

9

Q[W]

[cm³] C S B [°C] +5 0 -5 -10 -15 -20 -25 -30 -35 -400.5 0.5 0.5 30 1296 1078 933 759 621 501 380 307 249 201

0.75 0.75 0.5 40 1144 955 811 655 527 418 309 235 179 1360.75 0.75 0.5 50 984 826 693 562 451 354 256 200 157 123 ________________________

0.75 0.75 0.75 30 1626 1352 1170 952 779 628 477 386 312 2531 1 0.75 40 1435 1198 1017 822 661 525 387 295 224 171 ▪ Performance data are based on1 1 0.75 50 1235 1036 869 704 566 444 321 251 197 154 European Standard EN129001 1 1 30 1956 1626 1408 1145 937 755 573 464 375 304 ▪ Suction gas temperature = 20°C

1.5 1.5 1 40 1726 1441 1223 989 796 632 466 354 269 205 for R134a, R404A, R22 (5K suction1.5 1.5 1 50 1485 1246 1046 847 681 534 387 302 237 185 gas superheat for R717)1.5 1.5 1.5 30 2357 1960 1696 1379 1129 910 691 559 452 366 ▪ Liquid subcooling = 0 K1.5 1.5 1.5 40 2080 1736 1474 1192 959 761 561 427 325 247 ▪ * Recommended Power1.5 1.5 1.5 50 1789 1501 1260 1021 820 643 466 364 285 223 ________________________

0.5 0.5 0.5 30 1620 1347 1166 948 776 626 475 384 311 2520.75 0.75 0.5 40 1430 1193 1013 819 659 523 386 294 223 170 ▪按照欧标 EN12900测试数据0.75 0.75 0.5 50 1230 1032 866 702 564 442 320 251 196 153 ▪吸气温度 = 20°C用于 R134a,0.75 0.75 0.75 30 2033 1690 1463 1189 974 785 596 482 390 316 R404A, R22 (5 K吸气过热用

1 1 0.75 40 1794 1497 1471 1028 827 656 484 368 280 213 于 R717)1 1 0.75 50 1543 1295 1087 881 707 555 402 314 246 193 ▪液体附加冷却 = 0 K1 1 1 30 2445 2033 1760 1431 1172 944 717 580 469 380 ▪ *建议能量

1.5 1.5 1 40 2158 1801 1529 1236 995 789 582 443 337 256 ________________________

1.5 1.5 1 50 1856 1558 1307 1059 851 667 483 378 296 2321.5 1.5 1.5 30 2946 2449 2120 1724 1412 1138 864 699 565 457 ▪ Hasil perhitungan ini1.5 1.5 1.5 40 2600 2170 1843 1490 1198 951 701 534 406 309 berdasarkan pada standard1.5 1.5 1.5 50 2237 1877 1575 1276 1025 804 582 456 356 279 eropa EN12900

0.75 0.75 0.75 30 2058 1711 1481 1204 986 795 603 488 395 320 ▪ Suction gas temperature = 20°C1 1 0.75 40 1816 1516 1287 1041 837 664 490 373 283 216 for R134a, R404A, R22 (5 K suction1 1 0.75 50 1562 1311 1100 891 716 561 407 318 249 195 gas superheat for R717)1 1 1 30 2582 2146 1858 1511 1237 997 757 612 495 401 ▪ Liquid subcooling = 0 K

1.5 1.5 1 40 2278 1902 1615 1305 1050 833 615 468 356 271 ▪ * Disarankan untuk kapasitas1.5 1.5 1 50 1960 1644 1380 1118 898 704 510 399 312 244 ________________________

1.5 1.5 1.5 30 3105 2582 2235 1817 1488 1199 910 736 596 482



C S B

Model型号

Jenis

r.p.m.每分钟

转数

KecepatanMotor


KapasitasCylinder



Suhu PadaCondenser

2Q-2

800

27.2

1000

1200

1450

2Q-3

800

34.0

1000

1200

1450

2Q-4

800

43.1

1000

1200


10

1.5 1.5 1.5 30 3105 2582 2235 1817 1488 1199 910 736 596 4822 2 1.5 40 2740 2287 1942 1570 1263 1003 739 563 428 3262 2 1.5 50 2357 1978 1660 1345 1080 847 614 480 376 2942 2 2 30 3741 3111 2693 2189 1793 1445 1097 887 718 5812 2 2 40 3301 2756 2340 1892 1522 1208 891 678 515 3922 2 2 50 2840 2383 2000 1621 1302 1021 740 578 453 3541 1 1 30 2576 2142 1854 1508 1234 995 755 611 494 400

1.5 1.5 1 40 2273 1898 1611 1303 1048 832 613 467 355 2701.5 1.5 1 50 1956 1641 1377 1116 896 703 509 398 312 2441.5 1.5 1.5 30 3232 2687 2326 1891 1549 1248 948 766 620 5022 2 1.5 40 2852 2381 2021 1634 1315 1043 769 585 445 3392 2 1.5 50 2454 2059 1728 1400 1125 882 639 500 391 3062 2 2 30 3888 3233 2798 2275 1863 1501 1140 922 746 6043 3 2 40 3431 2864 2432 1966 1581 1255 926 704 535 4083 3 2 50 2952 2476 2078 1684 1353 1061 769 601 470 3683 3 3 30 4684 3895 3371 2741 2244 1809 1373 1111 898 7273 3 3 40 4133 3450 2930 2369 1905 1512 1115 849 645 4913 3 3 50 3556 2984 2504 2029 1630 1278 926 724 567 4441 1 1 30 3629 3018 2612 2124 1739 1402 1064 861 696 564

1.5 1.5 1 40 3203 2673 2270 1835 1476 1172 864 657 500 3811.5 1.5 1 50 2755 2312 1940 1572 1263 990 718 561 439 3441.5 1.5 1.5 30 4553 3786 3277 2664 2182 1758 1335 1080 873 7072 2 1.5 40 4018 3354 2848 2303 1852 1470 1084 825 627 4772 2 1.5 50 3457 2900 2434 1973 1584 1242 900 704 551 4312 2 2 30 5477 4554 3942 3205 2624 2115 1606 1299 1051 8513 3 2 40 4833 4034 3426 2770 2228 1768 1304 992 754 5743 3 2 50 4158 3489 2928 2373 1906 1495 1083 847 662 5193 3 3 30 6599 5487 4750 3861 3162 2548 1935 1565 1266 10253 3 3 40 5823 4861 4127 3337 2684 2130 1571 1195 909 6923 3 3 50 5010 4203 3528 2859 2296 1801 1305 1020 798 6253 2 2 30 8102 6736 5831 4741 3882 3129 2375 1921 1554 12583 2.5 2 40 7149 5967 5067 4097 3295 2615 1929 1468 1116 8493 2.5 2 50 6150 5160 4331 3510 2819 2211 1602 1253 980 7673 3 3 30 10164 8451 7315 5947 4870 3925 2980 2410 1949 1578 www.tongkian.sg

3.5 3 2.5 40 8968 7486 6357 5140 4134 3281 2420 1841 1400 10663.5 3 2.5 50 7716 6474 5434 4403 3536 2773 2009 1571 1229 9634 4 3 30 12226 10165 8800 7154 5858 4721 3584 2899 2345 1899

5.5 4 3 40 10788 9005 7647 6182 4973 3947 2911 2215 1684 12825.5 4 3 50 9281 7788 6536 5296 4254 3336 2417 1890 1479 11585.5 4 3 30 14730 12247 10602 8619 7058 5689 4318 3493 2825 22875.5 5.5 4 40 12998 10850 9213 7449 5992 4755 3507 2668 2029 1544

2Q-4 43.1

1200

1450

2Q-5

800

54.4

1000

1200

1450

1HVS

800

76

1000

1200

1450

2GVS

800

170

1000

1200

1450 5.5 5.5 4 40 12998 10850 9213 7449 5992 4755 3507 2668 2029 15445.5 5.5 4 50 11183 9383 7875 6381 5125 4019 2912 2278 1782 1395

2GVS 170

1450

10

Q[W]

[cm³] C S B [°C] +5 0 -5 -10 -15 -20 -25 -30 -35 -404 4 3 30 16295 13641 11056 8911 7057 5645 4231 3117 2299 1693

5.5 4 3 40 10398 8680 7370 5959 4793 3804 2805 2135 1623 1236- 5.5 4 50 - - - 6784 5110 3992 2871 1896 1250 824 ________________________

5.5 5.5 4 30 20369 17051 13820 11138 8822 7057 5289 3896 2874 21177.5 5.5 4 40 12998 10850 9213 7449 5992 4755 3507 2668 2029 1544 ▪ Performance data are based on

- 7.5 5.5 50 - - 9937 8479 6388 4990 3589 2370 1563 1030 European Standard EN129007.5 5.5 5.5 30 24442 20462 16584 13366 10586 8468 6346 4676 3448 2540 ▪ Suction gas temperature = 20°C10 7.5 5.5 40 15597 13020 11056 8938 7190 5706 4208 3202 2435 1853 for R134a, R404A, R22 (5K suction- - 5.5 50 - - - - - - 4306 2843 1876 1236 gas superheat for R717)

7.5 7.5 5.5 30 26479 22167 17966 14480 11468 9174 6875 5065 3736 2752 ▪ Liquid subcooling = 0 K10 10 7.5 40 16897 14105 11977 9683 7789 6182 4559 3469 2637 2008 ▪ * Recommended Power- - 10 50 - - - - - - 4665 3080 2032 1338 ________________________

10 10 7.5 30 34732 28803 23477 18899 15079 11834 8984 6734 4847 322810 10 7.5 40 30771 24908 20161 16238 12932 9643 7265 5249 3788 2736 ▪按照欧标 EN12900测试数据10 10 10 50 25508 21489 17185 13980 11035 8260 5873 3836 2722 1934 ▪吸气温度 = 20°C用于 R134a,10 10 10 30 41846 34702 28286 22770 18168 14258 10824 8113 5839 3890 R404A, R22 (5 K吸气过热用15 15 10 40 37074 30010 24291 19564 15580 11618 8753 6324 4564 3297 于 R717)15 15 15 50 30732 25891 20705 16844 13295 9952 7076 4622 3280 2330 ▪液体附加冷却 = 0 K15 15 15 30 45502 38002 31112 24898 20236 15808 12022 8999 6476 4317 ▪ *建议能量20 15 15 40 41241 32974 26658 21398 17437 12966 9816 6948 4918 3480 ________________________

20 20 15 50 34394 28870 23014 18580 14896 11112 7876 5579 3947 279415 15 15 30 57222 47791 39126 31311 25448 19880 15119 11317 8145 5429 ▪ Hasil perhitungan ini20 15 15 40 51863 41467 33524 26909 21929 16306 12344 8737 6185 4376 berdasarkan pada standard20 20 15 50 43253 36306 28942 23366 18732 13974 9905 7016 4964 3513 eropa EN1290020 20 20 30 68942 57579 47140 37724 30660 23952 18215 13635 9813 6541 ▪ Suction gas temperature = 20°C25 20 20 40 62486 49960 40391 32421 26420 19645 14873 10527 7452 5273 for R134a, R404A, R22 (5 K suction25 25 20 50 52113 43742 34870 28152 22569 16836 11933 8453 5981 4233 gas superheat for R717)25 25 20 30 95280 79545 64556 52159 41615 32543 24887 18341 13144 8951 ▪ Liquid subcooling = 0 K30 25 20 40 86049 68586 55326 44864 35370 27283 19978 14406 10387 7485 ▪ * Disarankan untuk kapasitas40 30 20 50 71317 59942 47758 38766 29180 22834 16326 11673 8347 - ________________________

30 25 20 30 114795 95838 77778 62842 50138 39208 29984 22098 15836 1078530 30 20 40 103674 82634 66658 54053 42614 32871 24069 17356 12514 9019


Suhu PadaCondenser



C S B

1000

Model型号

Jenis

r.p.m.每分钟

转数

KecepatanMotor


KapasitasCylinder



1245

3LVS

800

351

1000

1200

1300


1000

560

1200

51VSR51VSM

800

949

1200

1200

1450


11

30 30 20 40 103674 82634 66658 54053 42614 32871 24069 17356 12514 901940 40 25 50 85924 72219 57540 46707 35157 27511 19670 14064 10056 -40 30 30 30 138901 115964 94112 76039 60668 47442 36281 26739 19162 13050- 40 25 40 - - - 65404 51563 39774 29124 21001 15142 10912- - - 50 - - - - - - - - - -

40 40 30 30 131966 111304 90339 73674 58635 46436 35323 26152 18937 1287550 40 30 40 119440 96171 77383 63474 50037 39093 28522 20504 14734 1058760 50 30 50 98843 83895 66801 54696 41176 32605 23239 14499 9045 -50 50 40 30 159678 134678 109310 89145 70948 56187 42741 31644 22914 1557960 50 40 40 144523 116367 93633 76803 60545 47303 34511 24810 17829 12811- - 50 50 - - - - - 39453 28120 17544 10944 10189

50 40 40 30 165159 139461 113164 92274 73658 58206 44508 32847 23719 1620360 50 40 40 148932 119900 96771 79285 62443 48868 35639 25750 18599 1343760 50 40 50 123569 104833 83557 68509 51526 40775 29071 20725 14777 1053560 50 50 30 199842 168748 136928 111652 89126 70429 53855 39745 28701 1960675 60 50 40 180207 145079 117093 95935 75556 59131 43123 31158 22505 16259- 60 50 50 - - - 82895 62346 49337 35175 25077 17880 12748

60 50 40 30 185010 156223 126765 103365 82511 65202 49857 36795 26570 1815170 60 40 40 166832 134311 108403 88814 69948 54742 39923 28845 20834 1505280 70 50 50 138421 117433 93600 76743 57719 45675 32565 23216 16553 11801 www.tongkian.sg70 60 50 30 223862 189030 153386 125071 99838 78894 60327 44522 32150 2196280 70 60 40 201867 162516 131167 107466 84637 66238 48307 34902 25210 18213- 80 60 50 - - - 92859 69840 55267 39403 28091 20029 14280


1245

90VS

1450

2160

1750

1450

1750

80VS81VS

1450

1865

1750

67VS/6B68VS/6B

1450

1440

1750

11

Q[W]

[cm³] C S [°C] +15 +10 +5 0 -5 -10 -15

800 10 7.5 40 44220 36500 29700 23700 18600 14400 108900

1000 15 10 40 55300 45700 37100 29700 23200 17900 13500

1200 15 10 40 66300 54800 44600 35600 27900 21600 16300

800 15 15 40 75000 61900 50300 40300 31500 24400 18400

1000 20 15 40 93600 77400 62900 50300 39300 30400 23000

1200 20 20 40 112400 92900 75500 60400 47200 36600 27500

1000 25 20 40 122900 101500 82500 66000 51600 40000 30100

1200 30 25 40 147400 121800 99000 79300 62000 48000 36100

1450 40 30 40 178100 147200 119700 95800 74900 57900 43700

1000 30 25 40 142100 117400 95500 76400 59700 46200 34800

1200 40 30 40 170500 141000 114600 91700 71600 55500 41800

1450 40 40 40 206000 170300 138500 110800 86600 67000 50500

1000 40 30 40 184000 152128 123700 98900 77300 59900 45100

1200 40 40 40 220900 182500 148400 118700 92800 71800 54100 www.tongkian.sg1450 50 40 40 267000 220600 179300 143500 112100 86800 65400

1000 50 40 40 209760 173426 141018 112746 88122 68286 51414

1200 50 50 40 251826 208050 169176 135318 105792 81852 61674

1450 70 60 40 304380 251484 204402 163590 127794 98952 74556

___________________________________________________________________________________

▪ Performance data are based on European Standard EN12900▪ Suction gas temperature = 20°C for R134a, R404A, R22 (5K suction gas superheat for R717)▪ Liquid subcooling = 0 K


Evaporating Temperature /蒸发温度 / Suhu Pada Evaporator [°C]Model型号

Jenis

r.p.m.每分钟

转数

KecepatanMotor


KapasitasCylinder

HP-CV-PS *Power to

install


Suhu PadaCondenser

SC

1440

1865

216090VS

80VS81VS

67VS/6B68VS/6B


51VSR51VSM


560

949

1245


12

▪ Liquid subcooling = 0 K▪ * Recommended Power

___________________________________________________________________________________

▪按照欧标 EN12900测试数据▪吸气温度 = 20°C用于 R134a, R404A, R22 (5 K吸气过热用于 R717)▪液体附加冷却 = 0 K▪ *建议能量 ___________________________________________________________________________________

▪ Hasil perhitungan ini berdasarkan pada standard eropa EN12900▪ Suction gas temperature = 20°C for R134a, R404A, R22 (5K suction gas superheat for R717)▪ Liquid subcooling = 0 K▪ * Disarankan untuk kapasitas ___________________________________________________________________________________

12

°F °C KPA PSIG KPA PSIG KPA PSIG KPA PSIG KPA PSIG KPA PSIG KPA PSIG-76.0 -60 -53 16 -49 14 -57 17 -53 16 -75 22 -64 19 -35 10-68.8 -56 -41 12 -36 11 -46 14 -41 12 -68 20 -55 16 -21 6-61.6 -52 -27 8 -21 6 -34 10 -28 8 -60 18 -43 13 -1 0-54.4 -48 -11 3 -4 1 -19 6 -12 4 -49 14 -30 9 21 3-47.2 -44 8 1 16 2 -1 0 7 1 -37 11 -15 4 46 7-40.0 -40 30 4 39 6 19 3 28 4 -22 6 4 1 76 11-36.4 -38 42 6 52 8 30 4 40 5 -14 4 14 2 93 13-32.8 -36 55 8 66 10 43 6 53 8 -5 1 25 4 111 16-29.2 -34 69 10 81 12 55 8 67 10 5 1 36 5 130 19-25.6 -32 83 12 96 14 69 10 81 12 16 2 49 7 150 22-22.0 -30 99 14 113 16 84 12 97 14 27 4 62 9 173 25-18.4 -28 116 17 131 19 100 15 113 16 39 6 76 11 194 28-14.8 -26 134 19 150 22 117 17 131 19 52 8 92 13 221 32-11.2 -24 154 22 170 25 135 20 149 22 66 10 108 16 245 36-7.6 -22 174 25 192 28 154 22 169 25 81 12 125 18 273 40-4.0 -20 196 28 214 31 174 25 190 28 97 14 143 21 302 44-0.4 -18 219 32 238 35 195 28 212 31 114 17 163 24 332 483.2 -16 243 35 264 38 218 32 235 34 133 19 184 24 366 436.8 -14 269 39 291 42 242 35 260 38 152 22 205 30 399 58

10.4 -12 297 43 319 46 267 39 286 41 173 25 229 33 435 6314.0 -10 324 47 349 51 294 43 313 45 195 28 253 37 475 6917.6 -8 355 51 380 55 322 47 342 50 218 32 279 40 516 7521.2 -6 387 56 414 60 352 51 372 54 243 35 306 44 560 8124.8 -4 420 61 448 65 383 56 404 59 269 39 334 48 605 8828.4 -2 455 66 485 70 416 60 437 63 297 43 365 53 654 9532.0 0 493 72 524 76 450 65 472 68 326 47 396 57 704 10235.6 2 532 77 564 82 487 71 508 74 357 52 429 62 755 11039.2 4 572 83 606 88 525 76 547 79 390 57 464 67 811 11842.8 6 615 89 651 94 565 82 587 85 424 61 501 73 855 12446.4 8 660 96 697 101 606 88 628 91 461 67 539 78 928 13550.0 10 707 103 746 108 650 94 672 97 499 72 579 84 992 14453.6 12 756 110 797 116 696 101 717 104 539 78 621 90 1057 15357.2 14 808 117 850 123 744 108 765 111 581 84 665 96 1128 16460.8 16 862 125 905 131 794 115 814 118 625 91 711 103 1198 17464.4 18 918 133 963 140 846 123 865 125 672 97 759 110 1275 18568.0 20 976 142 1023 148 900 131 918 133 721 105 808 117 1350 19675.2 24 1101 160 1151 167 1016 147 1031 150 825 120 915 133 1520 22082.4 28 1236 179 1290 187 1142 166 1153 167 940 136 1029 149 1699 24689.6 32 1382 200 1440 209 1278 185 1284 186 1065 154 1154 167 1896 27596.8 36 1540 223 1602 232 1425 207 1425 207 1202 174 1288 187 2108 306

104.0 40 1711 248 1777 258 1583 230 1576 229 1350 196 1432 208 2335 339107.6 42 1800 261 1869 271 1666 242 1655 240 1429 207 1580 219 2454 356111.2 44 1894 275 1964 285 1753 254 1737 252 1511 219 1587 230 2581 374114.8 46 1990 289 2063 299 1842 267 1822 264 1597 232 1669 242 2708 393118.4 48 2090 303 2165 314 1935 281 1909 277 1686 245 1753 254 2843 412122.0 50 2194 318 2271 329 2031 295 2000 290 1778 258 1841 267 2980 432125.6 52 2301 334 2381 345 2131 309 2094 304 1874 272 1931 280 3125 453

SATURATED VAPOUR PRESSURES (FIGURES IN RED VACUUM INCHES & KPA)TEMP R404A R507 R408A R502 R407C R22 R410A

125.6 52 2301 334 2381 345 2131 309 2094 304 1874 272 1931 280 3125 453129.2 54 2412 350 2494 362 2234 324 2190 318 1974 286 2025 294 3271 474132.8 56 2526 366 2612 379 2341 340 2290 332 2078 301 2122 308 3428 497140.0 60 2767 401 2858 415 2564 372 2500 363 2297 333 2325 337 3747 543

P.O.E. For new medium & low temperature applications (Can replaceR502 but requires careful retro-fit procedure)

Oil Type

Refrigerant Reference GuideName Type

HFC Liqiud Only

Refrigerant Major Applications & Notes

R22

R407C

R410A

R134A

SP34E

R404A

R507

R408A

R502

R409A

R12

R123

R11 CFC Yes

No

No

Yes

Yes

Yes

No

No

No

No

Yes

Yes

Yes

HFC

HCFC

CFC

HCFC

HCFC

HFC

HCFC

CFC

For new medium & low temperature applications (Can replaceR502 but requires careful retro-fit procedure)

Interim replacement for R502 (Availiabity - Large scalereduction from 2005)

No longer manufactured (High ozone depleting factor) usedon freezers & medium temp application - see R408A,R404A,

R507

For air conditioning, medium & occasionally low tempapplications. (Availiabity - large scale reductions from 2005)

Note: The only different between R404a & R507 is R404a has 4% of R134a added (for patent reasons)

P.O.E.

Mineral / P.O.E.Alkylbenzene

Mineral or Alkylbenzene


P.O.E.

P.O.E.

P.O.E.






HFC

HFC

HFC

Liqiud Only

Liqiud Only

Liqiud or Vapour

Liqiud Only

Liqiud Only

Liqiud or Vapour

Liqiud Only

Liqiud Only

OzoneDepleting

ChargingSystem

No longer manufactured (High ozone depleting factor) usedon freezers & medium temp application - see R409A &

SP34E

Interim replacement for R11 -requires careful retro-fitprocedure (Availiabity -large scale reductions from 2005)

No longer manufactured (High ozone depleting factor) usedon centrifugal chiller application - see R123

For new larger to medium air condioning & some smallerapplications (Can replace R22 careful retro-fit procedure

required)

For new smaller (resdential type) air conditioning applications(requires high pressure components & service tools)

For new med. temp & domestic freezers, small commercialjobs (Can replace R12 & R500 - but requires careful retro-fit

procedures)

Interim replacement for R12 (Can be on flooded systems ie:temprite system)

Interim replacement for R12 (Not recommended for floodedsystems ie: temprite system)

Liqiud or Vapour

Liqiud Only

Liqiud or Vapour

Liqiud or Vapour

°F °C KPA PSIG KPA PSIG KPA PSIG KPA PSIG KPA PSIG KPA PSIG KPA PSIG-76.0 -60 -79 23 -100 30 -79 23-68.8 -56 -73 22 -99 29 -72 21-61.6 -52 -66 19 -99 29 -65 19-54.4 -48 -68 20 -68 20 -58 17 -98 29 -55 16-47.2 -44 -60 18 -60 18 -48 14 -97 29 -43 13-40.0 -40 -50 15 -50 15 -50 15 -37 11 -98 29 -96 28 -29 9-36.4 -38 -45 13 -45 13 -44 13 -31 9 -97 29 -95 28 -22 6-32.8 -36 -38 11 -38 11 -38 11 -24 7 -96 28 -94 28 -13 4-29.2 -34 -32 9 -31 9 -32 9 -17 5 -96 28 -94 28 -3 1-25.6 -32 -25 7 -25 7 -25 7 -9 3 -95 28 -93 27 13 2-22.0 -30 -17 5 -17 5 -17 5 -1 0 -94 28 -92 27 18 3-18.4 -28 -9 3 -9 3 -9 3 8 1 -93 27 -91 27 30 4-14.8 -26 0.3 0.1 0.5 0.1 -1 0 17 2 -92 27 -90 27 43 6-11.2 -24 10 1 10 1 9 1 27 4 -91 27 -88 26 57 8-7.6 -22 20 3 20 3 19 3 38 6 -90 27 -87 26 72 10-4.0 -20 31 4 32 5 29 4 50 7 -89 26 -85 25 89 13-0.4 -18 43 6 44 6 41 6 62 9 -88 26 -84 25 106 153.2 -16 56 8 56 8 53 8 75 11 -86 25 -82 24 125 186.8 -14 69 10 70 10 66 10 88 13 -84 25 -80 24 145 21

10.4 -12 84 12 84 12 80 12 103 15 -83 25 -78 23 167 2414.0 -10 99 14 100 15 95 14 118 17 -81 24 -76 22 190 2817.6 -8 115 17 116 17 111 16 134 19 -79 23 -73 22 214 3121.2 -6 133 19 134 19 127 18 151 22 -77 23 -70 21 240 3524.8 -4 151 22 152 22 145 21 169 25 -74 22 -67 20 268 3928.4 -2 171 25 172 25 164 24 187 27 -71 21 -64 19 298 4332.0 0 191 28 192 28 184 27 207 30 -69 20 -61 18 392 4835.6 2 213 31 215 31 205 30 228 33 -66 19 -57 17 362 5339.2 4 236 34 238 35 227 33 250 36 -62 18 -54 16 397 5842.8 6 260 38 262 38 250 36 273 40 -59 17 -50 15 434 6346.4 8 286 41 288 42 275 40 297 43 -55 16 -45 13 474 6950.0 10 313 45 316 46 301 44 322 47 -51 15 -41 12 515 7553.6 12 341 49 344 50 328 48 348 50 -46 14 -36 11 559 8157.2 14 371 54 375 54 357 52 376 55 -42 12 -31 9 605 8860.8 16 402 58 406 59 387 56 404 59 -37 11 -25 7 653 9564.4 18 435 63 440 64 419 61 434 63 -31 9 -19 6 704 10268.0 20 470 68 470 68 452 66 466 68 -26 8 -13 4 758 11075.2 24 544 79 557 81 524 76 533 77 -13 4 1 0 873 12782.4 28 625 91 623 90 602 87 605 88 1 0 16 2 1000 14589.6 32 713 103 698 101 687 100 683 99 16 2 33 5 1140 16596.8 36 810 117 792 115 781 113 768 111 34 5 51 7 1290 187

SATURATED VAPOUR PRESSURES (FIGURES IN RED VACUUM INCHES & KPA)TEMP R134A SP34E R409A R12 R123 R11 R717

96.8 36 810 117 792 115 781 113 768 111 34 5 51 7 1290 187104.0 40 915 133 880 128 882 128 859 125 53 8 72 10 1460 212107.6 42 970 141 927 134 936 136 907 132 64 9 83 12 1540 223111.2 44 1028 149 977 142 992 144 957 139 75 11 95 14 1630 236114.8 46 1089 158 1026 149 1051 152 1009 146 86 12 107 16 1730 251118.4 48 1151 167 1078 156 1111 161 1062 154 98 14 120 17 1830 265122.0 50 1216 176 1130 164 1174 170 1118 162 111 16 133 19 1930 280125.6 52 1284 186 1193 173 1240 180 1175 170 125 18 147 21 2040 296129.2 54 1354 196 1249 181 1308 190 1234 179 139 20 162 23 2155 313132.8 56 1427 207 1312 190 1379 200 1295 188 153 22 177 26 2270 329140.0 60 1581 229 1450 210 1529 222 1424 207 185 27 210 30 2510 364

3. Measure suction gas temperature on the line at the expansion valve bulb's remote location.

4. Subtract saturation temperature (from step 2) from suction gas temperature (from step3). The difference is the superheat of the suction gas.

HOW TO DETERMINE SUPERHEAT

1. Determine suction pressure at the eveporator outlet with gauge. On close coupled installations, suction pressure may be read at compressor suction connection.

2. Use pressure temperature chart to determine saturation temperature at observed suction pressure.

Documents

1LTZ035 APE 2012 Type.pdf · Flywheel 整速轮 Oil Charge ... 1 0.75 0.5 35 2508 2035 1637 1301 1009 766 566 Hasil perhitungan ini 1 0.75 0.5 45 2206 1787 1434 1136 877 661 484 berdasarkan