Upload
nguyentuyen
View
251
Download
1
Embed Size (px)
Citation preview
Installation Instructions
CompactLogix Controllers
Catalog Numbers 1768-L43 1768-L43S 1768-L45 1768-L45S
Topic PageImportant User Information 2
About CompactLogix Controllers 6
Verify Compatibility 6
Required System Components 7
Clearance Requirements 7
Module Placement 8
Install the Controller 9
Panel Mount the Controller 10
Mount the Controller on a DIN Rail 10
Confirm the Installation 13
Connect to the Controller 14
Configure a Communication Driver 14
Insert or Remove a CompactFlash Card 18
Install Controller Firmware 18
Remove a 1768 or 1769 Module from the DIN Rail 21
Status Indicators 23
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only) 25
Clear a Major Fault 26
Clear a Nonrecoverable Fault 27
Troubleshoot a Nonresponsive Module 27
Troubleshoot System Power 28
Specifications 32
Additional Resources 36
2 CompactLogix Controllers
Important User Information
Solid state equipment has operational characteristics differing from those of electromechanical equipment Safety Guidelines for the Application Installation and Maintenance of Solid State Controls (publication SGI-11 available from your local Rockwell Automation sales office or online at httpliteraturerockwellautomationcom) describes some important differences between solid state equipment and hard-wired electromechanical devices Because of this difference and also because of the wide variety of uses for solid state equipment all persons responsible for applying this equipment must satisfy themselves that each intended application of this equipment is acceptable
In no event will Rockwell Automation Inc be responsible or liable for indirect or consequential damages resulting from the use or application of this equipment
The examples and diagrams in this manual are included solely for illustrative purposes Because of the many variables and requirements associated with any particular installation Rockwell Automation Inc cannot assume responsibility or liability for actual use based on the examples and diagrams
No patent liability is assumed by Rockwell Automation Inc with respect to use of information circuits equipment or software described in this manual
Reproduction of the contents of this manual in whole or in part without written permission of Rockwell Automation Inc is prohibited
Throughout this manual when necessary we use notes to make you aware of safety considerations
WARNING Identifies information about practices or circumstances that can cause an explosion in a hazardous environment which may lead to personal injury or death property damage or economic loss
IMPORTANT Identifies information that is critical for successful application and understanding of the product
ATTENTION Identifies information about practices or circumstances that can lead to personal injury or death property damage or economic loss Attentions help you identify a hazard avoid a hazard and recognize the consequences
Labels may be on or inside the equipment for example drive or motor to alert people that dangerous voltage may be present
Labels may be on or inside the equipment for example drive or motor to alert people that surfaces may reach dangerous temperatures
SHOCK HAZARD
BURN HAZARD
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 3
Environment and Enclosure
ATTENTION This equipment is intended for use in a Pollution Degree 2 industrial environment in overvoltage Category II applications (as defined in IEC publication 60664-1) at altitudes up to 2000 m (6562 ft) without deratingThis equipment is considered Group 1 Class A industrial equipment according to IECCISPR Publication 11 Without appropriate precautions there may be difficulties with electromagnetic compatibility in residential and other environments due to conducted as well as radiated disturbancesThis equipment is supplied as open-type equipment It must be mounted within an enclosure that is suitably designed for those specific environmental conditions that will be present and appropriately designed to prevent personal injury resulting from accessibility to live parts The enclosure must have suitable flame-retardant properties to prevent or minimize the spread of flame complying with a flame spread rating of 5VA V2 V1 V0 (or equivalent) if non-metallic The interior of the enclosure must be accessible only by the use of a tool Subsequent sections of this publication may contain additional information regarding specific enclosure type ratings that are required to comply with certain product safety certificationsIn addition to this publication see
bull Industrial Automation Wiring and Grounding Guidelines Rockwell Automation publication 1770-41 for additional installation requirements
bull NEMA Standards 250 and IEC 60529 as applicable for explanations of the degrees of protection provided by different types of enclosure
Publication 1768-IN004D-EN-P - December 2009
4 CompactLogix Controllers
European Hazardous Location ApprovalConsider the following if you install a 1768-L43S or 1768-L45S controller in a European Zone 2 location
General Safety Information for 1768-L43S and 1768-L45S Controllers
European Zone 2 Certification (The following applies when the product bears the EX marking)
This equipment is intended for use in potentially explosive atmospheres as defined by European Union Directive 949EC and has been found to comply with the Essential Health and Safety Requirements relating to the design and construction of Category 3 equipment intended for use in Zone 2 potentially explosive atmospheres given in Annex II to this Directive
Compliance with the Essential Health and Safety Requirements has been assured by compliance with EN 60079-15 and EN 60079-0
WARNING bull This equipment must be installed in an enclosure providing at least IP54 protection when applied in Zone 2 environments
bull This equipment shall be used within its specified ratings defined by Allen-Bradley
bull Provision shall be made to prevent the rated voltage from being exceeded by transient disturbances of more than 40 when applied in Zone 2 environments
bull This equipment is not resistant to sunlight or other sources of UV radiation
bull Secure any external connections that mate to this equipment by using screws sliding latches threaded connectors or other means provided with this product
bull Do not disconnect equipment unless power has been removed or the area is known to be nonhazardous
ATTENTION Personnel responsible for the application of safety-related programmable electronic systems (PES) shall be aware of the safety requirements in the application of the system and shall be trained in using the system
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 5
North American Hazardous Location Approval
Preventing Electrostatic Discharge
The following information applies when operating this equipment in hazardous locations
Informations sur lrsquoutilisation de cet eacutequipement en environnements dangereux
Products marked CL I DIV 2 GP A B C D are suitable for use in Class I Division 2 Groups A B C D Hazardous Locations and nonhazardous locations only Each product is supplied with markings on the rating nameplate indicating the hazardous location temperature code When combining products within a system the most adverse temperature code (lowest T number) may be used to help determine the overall temperature code of the system Combinations of equipment in your system are subject to investigation by the local Authority Having Jurisdiction at the time of installation
Les produits marqueacutes CL I DIV 2 GP A B C D ne conviennent quagrave une utilisation en environnements de Classe I Division 2 Groupes A B C D dangereux et non dangereux Chaque produit est livreacute avec des marquages sur sa plaque didentification qui indiquent le code de tempeacuterature pour les environnements dangereux Lorsque plusieurs produits sont combineacutes dans un systegraveme le code de tempeacuterature le plus deacutefavorable (code de tempeacuterature le plus faible) peut ecirctre utiliseacute pour deacuteterminer le code de tempeacuterature global du systegraveme Les combinaisons deacutequipements dans le systegraveme sont sujettes agrave inspection par les autoriteacutes locales qualifieacutees au moment de linstallation
WARNING EXPLOSION HAZARD -bull Do not disconnect equipment unless
power has been removed or the area is known to be nonhazardous
bull Do not disconnect connections to this equipment unless power has been removed or the area is known to be nonhazardous Secure any external connections that mate to this equipment by using screws sliding latches threaded connectors or other means provided with this product
bull Substitution of components may impair suitability for Class I Division 2
bull If this product contains batteries they must only be changed in an area known to be nonhazardous
AVERTISSEMENT RISQUE DrsquoEXPLOSION ndash bull Couper le courant ou sassurer
que lenvironnement est classeacute non dangereux avant de deacutebrancher leacutequipement
bull Couper le courant ou sassurer que lenvironnement est classeacute non dangereux avant de deacutebrancher les connecteurs Fixer tous les connecteurs externes relieacutes agrave cet eacutequipement agrave laide de vis loquets coulissants connecteurs fileteacutes ou autres moyens fournis avec ce produit
bull La substitution de composants peut rendre cet eacutequipement inadapteacute agrave une utilisation en environnement de Classe I Division 2
bull Sassurer que lenvironnement est classeacute non dangereux avant de changer les piles
ATTENTION This equipment is sensitive to electrostatic discharge which can cause internal damage and affect normal operation Follow these guidelines when you handle this equipment
bull Touch a grounded object to discharge potential staticbull Wear an approved grounding wriststrapbull Do not touch connectors or pins on component boardsbull Do not touch circuit components inside the equipmentbull Use a static-safe workstation if availablebull Store the equipment in appropriate static-safe packaging when not in use
Publication 1768-IN004D-EN-P - December 2009
6 CompactLogix Controllers
About CompactLogix ControllersCompactLogix 1768-L43 and 1768-L45 controllers are designed to provide a Logix solution for medium-sized applications Compact GuardLogix controller catalog numbers end in lsquoSrsquo These safety controllers are wider than their standard counterparts
Verify Compatibility
This table shows the compatible RSLogix 5000 software versions and controller firmware revisions
IMPORTANT Attempting to use controllers with incompatible software and firmware revisions may result in
bull an inability to connect to the series B controller in RSLogix 5000 software
bull unsuccessful firmware upgrades in ControlFlash or AutoFlash utilities
Controllers RSLogix 5000 Software Version or Later
Controller Firmware Revision or Later
1768-L43 and 1768-L45 Series B
1603 1623
1768-L43S and 1768-L45S Series B
18 18
1768-L43 1768-L45 1768-L43S 1768-L45S
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 7
Required System ComponentsYou need these parts when installing your controller
bull 1768-L43 1768-L43S 1768-L45 or 1768-L45S CompactLogix controller
bull 1768-PA3 or 1768-PB3 power supply
bull 1769-ECR end cap
bull Mounting screws (M4 or 8 panhead) or one of these EN 50 022 DIN rails
ndash 35 x 75 mm (138 x 030 in)
ndash 35 x 15 mm (138 x 059 in)
bull 1756-CP3 serial cable (or make your own)
Clearance RequirementsAllow for the minimum clearance from enclosure walls wireways and other equipment
IMPORTANT These minimum clearances keep the modules cool enough in most situationsSee Specifications on page 32 for the acceptable temperature range
31609-M
PowerOUT
L1
L2N
90 mm(354 in)
105 mm (413 in)
90 mm(354 in)
105 mm (413 in)
Publication 1768-IN004D-EN-P - December 2009
8 CompactLogix Controllers
Module Placement
Follow these requirements to determine proper placement of your 1768 controller power supply 1768 IO modules and 1769 IO modules
bull Place the 1768-L4xx controller so that it is the last module (furthest away from the power supply) in the 1768 backplane
bull The 1768 CompactLogix power supply distributes power from the right side of the supply and must be the leftmost module in the system
bull Up to eight 1769 IO modules can reside in the local bank
bull The local bank is powered by a 1768 power supply
bull Up to two remote banks of 1769 IO modules may be connected by using 1769-CRLx extension cables
bull Remote banks are powered by a standard 1769 power supply
IMPORTANT CompactLogix System Distance RatingsBecause the 1768 CompactLogix power supply works with the controller to power a 1768 system the distance rating in a 1768 CompactLogix system differs from that in a 1769 CompactLogix systemIn the 1768 system the distance rating is the distance between 1769 IO modules and the controller In the 1769 system the distance rating is the distance between 1769 IO modules and the power supply
1768 Backplane (local) 1768 Controller Power
Supply and IO ModulesRemote Bank
1769 Power Supply andIO Modules
1769 Backplane
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 9
bull Up to eight 1769 Compact IO modules can reside on each side of a 1769 power supply in a remote bank Consult the modulersquos specifications for its distance rating
bull The type of controller determines the maximum number of 1768 modules that can reside in the local bank and the maximum number of 1769 IO modules that can reside in one local and up to two remote banks
Install the ControllerFollow these steps to install your controller
1 Mount the controller to a panel or on a DIN rail
2 Confirm the installation
3 Connect the controller
4 Configure a serial or Ethernet driver
5 Install a CompactFlash card (optional)
6 Download and install controller firmware
IMPORTANT Never place a 1769 power supply in a local bank with a 1768 controller or a major fault will occur
Controller Max Local 1768 Modules
Max 1769 IO Modules(local and remote)
1768-L43 1768-L43S 2 16
1768-L45 1768-L45S 4 30
IMPORTANT Do not use screws if using a DIN rail to mount the controller You can break the mounting tabs if you screw the controller to a panel while it is on a DIN rail
Publication 1768-IN004D-EN-P - December 2009
10 CompactLogix Controllers
Panel Mount the ControllerFollow these steps to mount your controller by using the panhead screws
1 Connect the CompactLogix modules together as shown in Mount the Controller on a DIN Rail on page 10
2 Use the controller as a template and mark pilot holes on your panel
3 Drill the pilot holes for M4 or 8 screws
4 Use M4 or 8 screws to mount the controller to your panel with 116 Nbullm (10 lbbullin) of torque
5 Ground the module on a ground bus with a dedicated earth ground stake
6 Connect the ground bus to a functional earth ground on the panel or a DIN rail
Mount the Controller on a DIN Rail
ATTENTION During mounting of all devices be sure that all debris (such as metal chips or wire strands) is kept from falling into the controller or IO modules Debris that falls into the controller or modules could cause damage while the controller is energized
ATTENTION This product is grounded through the DIN rail to chassis ground Use zinc plated yellow-chromate steel DIN rail to assure proper grounding The use of other DIN rail materials (for example aluminum and plastic) that can corrode oxidize or are poor conductors can result in improper or intermittent grounding Secure DIN rail to the mounting surface approximately every 200 mm (787 in) and use end anchors appropriately
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN ltFEFF004200720075006700200069006e0064007300740069006c006c0069006e006700650072006e0065002000740069006c0020006100740020006f007000720065007400740065002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e007400650072002000740069006c0020006b00760061006c00690074006500740073007500640073006b007200690076006e0069006e006700200065006c006c006500720020006b006f007200720065006b007400750072006c00e60073006e0069006e0067002e0020004400650020006f007000720065007400740065006400650020005000440046002d0064006f006b0075006d0065006e0074006500720020006b0061006e002000e50062006e00650073002000690020004100630072006f00620061007400200065006c006c006500720020004100630072006f006200610074002000520065006100640065007200200035002e00300020006f00670020006e0079006500720065002egt DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB ltFEFF005500740069006c0069007a006500200065007300730061007300200063006f006e00660069006700750072006100e700f50065007300200064006500200066006f0072006d00610020006100200063007200690061007200200064006f00630075006d0065006e0074006f0073002000410064006f0062006500200050004400460020007000610072006100200069006d0070007200650073007300f5006500730020006400650020007100750061006c0069006400610064006500200065006d00200069006d00700072006500730073006f0072006100730020006400650073006b0074006f00700020006500200064006900730070006f00730069007400690076006f0073002000640065002000700072006f00760061002e0020004f007300200064006f00630075006d0065006e0074006f00730020005000440046002000630072006900610064006f007300200070006f00640065006d0020007300650072002000610062006500720074006f007300200063006f006d0020006f0020004100630072006f006200610074002000650020006f002000410064006f00620065002000520065006100640065007200200035002e0030002000650020007600650072007300f50065007300200070006f00730074006500720069006f007200650073002egt SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
2 CompactLogix Controllers
Important User Information
Solid state equipment has operational characteristics differing from those of electromechanical equipment Safety Guidelines for the Application Installation and Maintenance of Solid State Controls (publication SGI-11 available from your local Rockwell Automation sales office or online at httpliteraturerockwellautomationcom) describes some important differences between solid state equipment and hard-wired electromechanical devices Because of this difference and also because of the wide variety of uses for solid state equipment all persons responsible for applying this equipment must satisfy themselves that each intended application of this equipment is acceptable
In no event will Rockwell Automation Inc be responsible or liable for indirect or consequential damages resulting from the use or application of this equipment
The examples and diagrams in this manual are included solely for illustrative purposes Because of the many variables and requirements associated with any particular installation Rockwell Automation Inc cannot assume responsibility or liability for actual use based on the examples and diagrams
No patent liability is assumed by Rockwell Automation Inc with respect to use of information circuits equipment or software described in this manual
Reproduction of the contents of this manual in whole or in part without written permission of Rockwell Automation Inc is prohibited
Throughout this manual when necessary we use notes to make you aware of safety considerations
WARNING Identifies information about practices or circumstances that can cause an explosion in a hazardous environment which may lead to personal injury or death property damage or economic loss
IMPORTANT Identifies information that is critical for successful application and understanding of the product
ATTENTION Identifies information about practices or circumstances that can lead to personal injury or death property damage or economic loss Attentions help you identify a hazard avoid a hazard and recognize the consequences
Labels may be on or inside the equipment for example drive or motor to alert people that dangerous voltage may be present
Labels may be on or inside the equipment for example drive or motor to alert people that surfaces may reach dangerous temperatures
SHOCK HAZARD
BURN HAZARD
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 3
Environment and Enclosure
ATTENTION This equipment is intended for use in a Pollution Degree 2 industrial environment in overvoltage Category II applications (as defined in IEC publication 60664-1) at altitudes up to 2000 m (6562 ft) without deratingThis equipment is considered Group 1 Class A industrial equipment according to IECCISPR Publication 11 Without appropriate precautions there may be difficulties with electromagnetic compatibility in residential and other environments due to conducted as well as radiated disturbancesThis equipment is supplied as open-type equipment It must be mounted within an enclosure that is suitably designed for those specific environmental conditions that will be present and appropriately designed to prevent personal injury resulting from accessibility to live parts The enclosure must have suitable flame-retardant properties to prevent or minimize the spread of flame complying with a flame spread rating of 5VA V2 V1 V0 (or equivalent) if non-metallic The interior of the enclosure must be accessible only by the use of a tool Subsequent sections of this publication may contain additional information regarding specific enclosure type ratings that are required to comply with certain product safety certificationsIn addition to this publication see
bull Industrial Automation Wiring and Grounding Guidelines Rockwell Automation publication 1770-41 for additional installation requirements
bull NEMA Standards 250 and IEC 60529 as applicable for explanations of the degrees of protection provided by different types of enclosure
Publication 1768-IN004D-EN-P - December 2009
4 CompactLogix Controllers
European Hazardous Location ApprovalConsider the following if you install a 1768-L43S or 1768-L45S controller in a European Zone 2 location
General Safety Information for 1768-L43S and 1768-L45S Controllers
European Zone 2 Certification (The following applies when the product bears the EX marking)
This equipment is intended for use in potentially explosive atmospheres as defined by European Union Directive 949EC and has been found to comply with the Essential Health and Safety Requirements relating to the design and construction of Category 3 equipment intended for use in Zone 2 potentially explosive atmospheres given in Annex II to this Directive
Compliance with the Essential Health and Safety Requirements has been assured by compliance with EN 60079-15 and EN 60079-0
WARNING bull This equipment must be installed in an enclosure providing at least IP54 protection when applied in Zone 2 environments
bull This equipment shall be used within its specified ratings defined by Allen-Bradley
bull Provision shall be made to prevent the rated voltage from being exceeded by transient disturbances of more than 40 when applied in Zone 2 environments
bull This equipment is not resistant to sunlight or other sources of UV radiation
bull Secure any external connections that mate to this equipment by using screws sliding latches threaded connectors or other means provided with this product
bull Do not disconnect equipment unless power has been removed or the area is known to be nonhazardous
ATTENTION Personnel responsible for the application of safety-related programmable electronic systems (PES) shall be aware of the safety requirements in the application of the system and shall be trained in using the system
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 5
North American Hazardous Location Approval
Preventing Electrostatic Discharge
The following information applies when operating this equipment in hazardous locations
Informations sur lrsquoutilisation de cet eacutequipement en environnements dangereux
Products marked CL I DIV 2 GP A B C D are suitable for use in Class I Division 2 Groups A B C D Hazardous Locations and nonhazardous locations only Each product is supplied with markings on the rating nameplate indicating the hazardous location temperature code When combining products within a system the most adverse temperature code (lowest T number) may be used to help determine the overall temperature code of the system Combinations of equipment in your system are subject to investigation by the local Authority Having Jurisdiction at the time of installation
Les produits marqueacutes CL I DIV 2 GP A B C D ne conviennent quagrave une utilisation en environnements de Classe I Division 2 Groupes A B C D dangereux et non dangereux Chaque produit est livreacute avec des marquages sur sa plaque didentification qui indiquent le code de tempeacuterature pour les environnements dangereux Lorsque plusieurs produits sont combineacutes dans un systegraveme le code de tempeacuterature le plus deacutefavorable (code de tempeacuterature le plus faible) peut ecirctre utiliseacute pour deacuteterminer le code de tempeacuterature global du systegraveme Les combinaisons deacutequipements dans le systegraveme sont sujettes agrave inspection par les autoriteacutes locales qualifieacutees au moment de linstallation
WARNING EXPLOSION HAZARD -bull Do not disconnect equipment unless
power has been removed or the area is known to be nonhazardous
bull Do not disconnect connections to this equipment unless power has been removed or the area is known to be nonhazardous Secure any external connections that mate to this equipment by using screws sliding latches threaded connectors or other means provided with this product
bull Substitution of components may impair suitability for Class I Division 2
bull If this product contains batteries they must only be changed in an area known to be nonhazardous
AVERTISSEMENT RISQUE DrsquoEXPLOSION ndash bull Couper le courant ou sassurer
que lenvironnement est classeacute non dangereux avant de deacutebrancher leacutequipement
bull Couper le courant ou sassurer que lenvironnement est classeacute non dangereux avant de deacutebrancher les connecteurs Fixer tous les connecteurs externes relieacutes agrave cet eacutequipement agrave laide de vis loquets coulissants connecteurs fileteacutes ou autres moyens fournis avec ce produit
bull La substitution de composants peut rendre cet eacutequipement inadapteacute agrave une utilisation en environnement de Classe I Division 2
bull Sassurer que lenvironnement est classeacute non dangereux avant de changer les piles
ATTENTION This equipment is sensitive to electrostatic discharge which can cause internal damage and affect normal operation Follow these guidelines when you handle this equipment
bull Touch a grounded object to discharge potential staticbull Wear an approved grounding wriststrapbull Do not touch connectors or pins on component boardsbull Do not touch circuit components inside the equipmentbull Use a static-safe workstation if availablebull Store the equipment in appropriate static-safe packaging when not in use
Publication 1768-IN004D-EN-P - December 2009
6 CompactLogix Controllers
About CompactLogix ControllersCompactLogix 1768-L43 and 1768-L45 controllers are designed to provide a Logix solution for medium-sized applications Compact GuardLogix controller catalog numbers end in lsquoSrsquo These safety controllers are wider than their standard counterparts
Verify Compatibility
This table shows the compatible RSLogix 5000 software versions and controller firmware revisions
IMPORTANT Attempting to use controllers with incompatible software and firmware revisions may result in
bull an inability to connect to the series B controller in RSLogix 5000 software
bull unsuccessful firmware upgrades in ControlFlash or AutoFlash utilities
Controllers RSLogix 5000 Software Version or Later
Controller Firmware Revision or Later
1768-L43 and 1768-L45 Series B
1603 1623
1768-L43S and 1768-L45S Series B
18 18
1768-L43 1768-L45 1768-L43S 1768-L45S
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 7
Required System ComponentsYou need these parts when installing your controller
bull 1768-L43 1768-L43S 1768-L45 or 1768-L45S CompactLogix controller
bull 1768-PA3 or 1768-PB3 power supply
bull 1769-ECR end cap
bull Mounting screws (M4 or 8 panhead) or one of these EN 50 022 DIN rails
ndash 35 x 75 mm (138 x 030 in)
ndash 35 x 15 mm (138 x 059 in)
bull 1756-CP3 serial cable (or make your own)
Clearance RequirementsAllow for the minimum clearance from enclosure walls wireways and other equipment
IMPORTANT These minimum clearances keep the modules cool enough in most situationsSee Specifications on page 32 for the acceptable temperature range
31609-M
PowerOUT
L1
L2N
90 mm(354 in)
105 mm (413 in)
90 mm(354 in)
105 mm (413 in)
Publication 1768-IN004D-EN-P - December 2009
8 CompactLogix Controllers
Module Placement
Follow these requirements to determine proper placement of your 1768 controller power supply 1768 IO modules and 1769 IO modules
bull Place the 1768-L4xx controller so that it is the last module (furthest away from the power supply) in the 1768 backplane
bull The 1768 CompactLogix power supply distributes power from the right side of the supply and must be the leftmost module in the system
bull Up to eight 1769 IO modules can reside in the local bank
bull The local bank is powered by a 1768 power supply
bull Up to two remote banks of 1769 IO modules may be connected by using 1769-CRLx extension cables
bull Remote banks are powered by a standard 1769 power supply
IMPORTANT CompactLogix System Distance RatingsBecause the 1768 CompactLogix power supply works with the controller to power a 1768 system the distance rating in a 1768 CompactLogix system differs from that in a 1769 CompactLogix systemIn the 1768 system the distance rating is the distance between 1769 IO modules and the controller In the 1769 system the distance rating is the distance between 1769 IO modules and the power supply
1768 Backplane (local) 1768 Controller Power
Supply and IO ModulesRemote Bank
1769 Power Supply andIO Modules
1769 Backplane
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 9
bull Up to eight 1769 Compact IO modules can reside on each side of a 1769 power supply in a remote bank Consult the modulersquos specifications for its distance rating
bull The type of controller determines the maximum number of 1768 modules that can reside in the local bank and the maximum number of 1769 IO modules that can reside in one local and up to two remote banks
Install the ControllerFollow these steps to install your controller
1 Mount the controller to a panel or on a DIN rail
2 Confirm the installation
3 Connect the controller
4 Configure a serial or Ethernet driver
5 Install a CompactFlash card (optional)
6 Download and install controller firmware
IMPORTANT Never place a 1769 power supply in a local bank with a 1768 controller or a major fault will occur
Controller Max Local 1768 Modules
Max 1769 IO Modules(local and remote)
1768-L43 1768-L43S 2 16
1768-L45 1768-L45S 4 30
IMPORTANT Do not use screws if using a DIN rail to mount the controller You can break the mounting tabs if you screw the controller to a panel while it is on a DIN rail
Publication 1768-IN004D-EN-P - December 2009
10 CompactLogix Controllers
Panel Mount the ControllerFollow these steps to mount your controller by using the panhead screws
1 Connect the CompactLogix modules together as shown in Mount the Controller on a DIN Rail on page 10
2 Use the controller as a template and mark pilot holes on your panel
3 Drill the pilot holes for M4 or 8 screws
4 Use M4 or 8 screws to mount the controller to your panel with 116 Nbullm (10 lbbullin) of torque
5 Ground the module on a ground bus with a dedicated earth ground stake
6 Connect the ground bus to a functional earth ground on the panel or a DIN rail
Mount the Controller on a DIN Rail
ATTENTION During mounting of all devices be sure that all debris (such as metal chips or wire strands) is kept from falling into the controller or IO modules Debris that falls into the controller or modules could cause damage while the controller is energized
ATTENTION This product is grounded through the DIN rail to chassis ground Use zinc plated yellow-chromate steel DIN rail to assure proper grounding The use of other DIN rail materials (for example aluminum and plastic) that can corrode oxidize or are poor conductors can result in improper or intermittent grounding Secure DIN rail to the mounting surface approximately every 200 mm (787 in) and use end anchors appropriately
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU ltFEFF00560065007200770065006e00640065006e0020005300690065002000640069006500730065002000450069006e007300740065006c006c0075006e00670065006e0020007a0075006d002000450072007300740065006c006c0065006e00200076006f006e002000410064006f006200650020005000440046002d0044006f006b0075006d0065006e00740065006e002c00200076006f006e002000640065006e0065006e002000530069006500200068006f00630068007700650072007400690067006500200044007200750063006b006500200061007500660020004400650073006b0074006f0070002d0044007200750063006b00650072006e00200075006e0064002000500072006f006f0066002d00470065007200e400740065006e002000650072007a0065007500670065006e0020006d00f60063006800740065006e002e002000450072007300740065006c006c007400650020005000440046002d0044006f006b0075006d0065006e007400650020006b00f6006e006e0065006e0020006d006900740020004100630072006f00620061007400200075006e0064002000410064006f00620065002000520065006100640065007200200035002e00300020006f0064006500720020006800f600680065007200200067006500f600660066006e00650074002000770065007200640065006e002egt ESP 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 FRA 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 ITA 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 JPN ltFEFF9ad854c18cea51fa529b7528002000410064006f0062006500200050004400460020658766f8306e4f5c6210306b4f7f75283057307e30593002537052376642306e753b8cea3092670059279650306b4fdd306430533068304c3067304d307e3059300230c730b930af30c830c330d730d730ea30f330bf3067306e53705237307e305f306f30d730eb30fc30d57528306b9069305730663044307e305930023053306e8a2d5b9a30674f5c62103055308c305f0020005000440046002030d530a130a430eb306f3001004100630072006f0062006100740020304a30883073002000410064006f00620065002000520065006100640065007200200035002e003000204ee5964d3067958b304f30533068304c3067304d307e30593002gt KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 3
Environment and Enclosure
ATTENTION This equipment is intended for use in a Pollution Degree 2 industrial environment in overvoltage Category II applications (as defined in IEC publication 60664-1) at altitudes up to 2000 m (6562 ft) without deratingThis equipment is considered Group 1 Class A industrial equipment according to IECCISPR Publication 11 Without appropriate precautions there may be difficulties with electromagnetic compatibility in residential and other environments due to conducted as well as radiated disturbancesThis equipment is supplied as open-type equipment It must be mounted within an enclosure that is suitably designed for those specific environmental conditions that will be present and appropriately designed to prevent personal injury resulting from accessibility to live parts The enclosure must have suitable flame-retardant properties to prevent or minimize the spread of flame complying with a flame spread rating of 5VA V2 V1 V0 (or equivalent) if non-metallic The interior of the enclosure must be accessible only by the use of a tool Subsequent sections of this publication may contain additional information regarding specific enclosure type ratings that are required to comply with certain product safety certificationsIn addition to this publication see
bull Industrial Automation Wiring and Grounding Guidelines Rockwell Automation publication 1770-41 for additional installation requirements
bull NEMA Standards 250 and IEC 60529 as applicable for explanations of the degrees of protection provided by different types of enclosure
Publication 1768-IN004D-EN-P - December 2009
4 CompactLogix Controllers
European Hazardous Location ApprovalConsider the following if you install a 1768-L43S or 1768-L45S controller in a European Zone 2 location
General Safety Information for 1768-L43S and 1768-L45S Controllers
European Zone 2 Certification (The following applies when the product bears the EX marking)
This equipment is intended for use in potentially explosive atmospheres as defined by European Union Directive 949EC and has been found to comply with the Essential Health and Safety Requirements relating to the design and construction of Category 3 equipment intended for use in Zone 2 potentially explosive atmospheres given in Annex II to this Directive
Compliance with the Essential Health and Safety Requirements has been assured by compliance with EN 60079-15 and EN 60079-0
WARNING bull This equipment must be installed in an enclosure providing at least IP54 protection when applied in Zone 2 environments
bull This equipment shall be used within its specified ratings defined by Allen-Bradley
bull Provision shall be made to prevent the rated voltage from being exceeded by transient disturbances of more than 40 when applied in Zone 2 environments
bull This equipment is not resistant to sunlight or other sources of UV radiation
bull Secure any external connections that mate to this equipment by using screws sliding latches threaded connectors or other means provided with this product
bull Do not disconnect equipment unless power has been removed or the area is known to be nonhazardous
ATTENTION Personnel responsible for the application of safety-related programmable electronic systems (PES) shall be aware of the safety requirements in the application of the system and shall be trained in using the system
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 5
North American Hazardous Location Approval
Preventing Electrostatic Discharge
The following information applies when operating this equipment in hazardous locations
Informations sur lrsquoutilisation de cet eacutequipement en environnements dangereux
Products marked CL I DIV 2 GP A B C D are suitable for use in Class I Division 2 Groups A B C D Hazardous Locations and nonhazardous locations only Each product is supplied with markings on the rating nameplate indicating the hazardous location temperature code When combining products within a system the most adverse temperature code (lowest T number) may be used to help determine the overall temperature code of the system Combinations of equipment in your system are subject to investigation by the local Authority Having Jurisdiction at the time of installation
Les produits marqueacutes CL I DIV 2 GP A B C D ne conviennent quagrave une utilisation en environnements de Classe I Division 2 Groupes A B C D dangereux et non dangereux Chaque produit est livreacute avec des marquages sur sa plaque didentification qui indiquent le code de tempeacuterature pour les environnements dangereux Lorsque plusieurs produits sont combineacutes dans un systegraveme le code de tempeacuterature le plus deacutefavorable (code de tempeacuterature le plus faible) peut ecirctre utiliseacute pour deacuteterminer le code de tempeacuterature global du systegraveme Les combinaisons deacutequipements dans le systegraveme sont sujettes agrave inspection par les autoriteacutes locales qualifieacutees au moment de linstallation
WARNING EXPLOSION HAZARD -bull Do not disconnect equipment unless
power has been removed or the area is known to be nonhazardous
bull Do not disconnect connections to this equipment unless power has been removed or the area is known to be nonhazardous Secure any external connections that mate to this equipment by using screws sliding latches threaded connectors or other means provided with this product
bull Substitution of components may impair suitability for Class I Division 2
bull If this product contains batteries they must only be changed in an area known to be nonhazardous
AVERTISSEMENT RISQUE DrsquoEXPLOSION ndash bull Couper le courant ou sassurer
que lenvironnement est classeacute non dangereux avant de deacutebrancher leacutequipement
bull Couper le courant ou sassurer que lenvironnement est classeacute non dangereux avant de deacutebrancher les connecteurs Fixer tous les connecteurs externes relieacutes agrave cet eacutequipement agrave laide de vis loquets coulissants connecteurs fileteacutes ou autres moyens fournis avec ce produit
bull La substitution de composants peut rendre cet eacutequipement inadapteacute agrave une utilisation en environnement de Classe I Division 2
bull Sassurer que lenvironnement est classeacute non dangereux avant de changer les piles
ATTENTION This equipment is sensitive to electrostatic discharge which can cause internal damage and affect normal operation Follow these guidelines when you handle this equipment
bull Touch a grounded object to discharge potential staticbull Wear an approved grounding wriststrapbull Do not touch connectors or pins on component boardsbull Do not touch circuit components inside the equipmentbull Use a static-safe workstation if availablebull Store the equipment in appropriate static-safe packaging when not in use
Publication 1768-IN004D-EN-P - December 2009
6 CompactLogix Controllers
About CompactLogix ControllersCompactLogix 1768-L43 and 1768-L45 controllers are designed to provide a Logix solution for medium-sized applications Compact GuardLogix controller catalog numbers end in lsquoSrsquo These safety controllers are wider than their standard counterparts
Verify Compatibility
This table shows the compatible RSLogix 5000 software versions and controller firmware revisions
IMPORTANT Attempting to use controllers with incompatible software and firmware revisions may result in
bull an inability to connect to the series B controller in RSLogix 5000 software
bull unsuccessful firmware upgrades in ControlFlash or AutoFlash utilities
Controllers RSLogix 5000 Software Version or Later
Controller Firmware Revision or Later
1768-L43 and 1768-L45 Series B
1603 1623
1768-L43S and 1768-L45S Series B
18 18
1768-L43 1768-L45 1768-L43S 1768-L45S
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 7
Required System ComponentsYou need these parts when installing your controller
bull 1768-L43 1768-L43S 1768-L45 or 1768-L45S CompactLogix controller
bull 1768-PA3 or 1768-PB3 power supply
bull 1769-ECR end cap
bull Mounting screws (M4 or 8 panhead) or one of these EN 50 022 DIN rails
ndash 35 x 75 mm (138 x 030 in)
ndash 35 x 15 mm (138 x 059 in)
bull 1756-CP3 serial cable (or make your own)
Clearance RequirementsAllow for the minimum clearance from enclosure walls wireways and other equipment
IMPORTANT These minimum clearances keep the modules cool enough in most situationsSee Specifications on page 32 for the acceptable temperature range
31609-M
PowerOUT
L1
L2N
90 mm(354 in)
105 mm (413 in)
90 mm(354 in)
105 mm (413 in)
Publication 1768-IN004D-EN-P - December 2009
8 CompactLogix Controllers
Module Placement
Follow these requirements to determine proper placement of your 1768 controller power supply 1768 IO modules and 1769 IO modules
bull Place the 1768-L4xx controller so that it is the last module (furthest away from the power supply) in the 1768 backplane
bull The 1768 CompactLogix power supply distributes power from the right side of the supply and must be the leftmost module in the system
bull Up to eight 1769 IO modules can reside in the local bank
bull The local bank is powered by a 1768 power supply
bull Up to two remote banks of 1769 IO modules may be connected by using 1769-CRLx extension cables
bull Remote banks are powered by a standard 1769 power supply
IMPORTANT CompactLogix System Distance RatingsBecause the 1768 CompactLogix power supply works with the controller to power a 1768 system the distance rating in a 1768 CompactLogix system differs from that in a 1769 CompactLogix systemIn the 1768 system the distance rating is the distance between 1769 IO modules and the controller In the 1769 system the distance rating is the distance between 1769 IO modules and the power supply
1768 Backplane (local) 1768 Controller Power
Supply and IO ModulesRemote Bank
1769 Power Supply andIO Modules
1769 Backplane
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 9
bull Up to eight 1769 Compact IO modules can reside on each side of a 1769 power supply in a remote bank Consult the modulersquos specifications for its distance rating
bull The type of controller determines the maximum number of 1768 modules that can reside in the local bank and the maximum number of 1769 IO modules that can reside in one local and up to two remote banks
Install the ControllerFollow these steps to install your controller
1 Mount the controller to a panel or on a DIN rail
2 Confirm the installation
3 Connect the controller
4 Configure a serial or Ethernet driver
5 Install a CompactFlash card (optional)
6 Download and install controller firmware
IMPORTANT Never place a 1769 power supply in a local bank with a 1768 controller or a major fault will occur
Controller Max Local 1768 Modules
Max 1769 IO Modules(local and remote)
1768-L43 1768-L43S 2 16
1768-L45 1768-L45S 4 30
IMPORTANT Do not use screws if using a DIN rail to mount the controller You can break the mounting tabs if you screw the controller to a panel while it is on a DIN rail
Publication 1768-IN004D-EN-P - December 2009
10 CompactLogix Controllers
Panel Mount the ControllerFollow these steps to mount your controller by using the panhead screws
1 Connect the CompactLogix modules together as shown in Mount the Controller on a DIN Rail on page 10
2 Use the controller as a template and mark pilot holes on your panel
3 Drill the pilot holes for M4 or 8 screws
4 Use M4 or 8 screws to mount the controller to your panel with 116 Nbullm (10 lbbullin) of torque
5 Ground the module on a ground bus with a dedicated earth ground stake
6 Connect the ground bus to a functional earth ground on the panel or a DIN rail
Mount the Controller on a DIN Rail
ATTENTION During mounting of all devices be sure that all debris (such as metal chips or wire strands) is kept from falling into the controller or IO modules Debris that falls into the controller or modules could cause damage while the controller is energized
ATTENTION This product is grounded through the DIN rail to chassis ground Use zinc plated yellow-chromate steel DIN rail to assure proper grounding The use of other DIN rail materials (for example aluminum and plastic) that can corrode oxidize or are poor conductors can result in improper or intermittent grounding Secure DIN rail to the mounting surface approximately every 200 mm (787 in) and use end anchors appropriately
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
4 CompactLogix Controllers
European Hazardous Location ApprovalConsider the following if you install a 1768-L43S or 1768-L45S controller in a European Zone 2 location
General Safety Information for 1768-L43S and 1768-L45S Controllers
European Zone 2 Certification (The following applies when the product bears the EX marking)
This equipment is intended for use in potentially explosive atmospheres as defined by European Union Directive 949EC and has been found to comply with the Essential Health and Safety Requirements relating to the design and construction of Category 3 equipment intended for use in Zone 2 potentially explosive atmospheres given in Annex II to this Directive
Compliance with the Essential Health and Safety Requirements has been assured by compliance with EN 60079-15 and EN 60079-0
WARNING bull This equipment must be installed in an enclosure providing at least IP54 protection when applied in Zone 2 environments
bull This equipment shall be used within its specified ratings defined by Allen-Bradley
bull Provision shall be made to prevent the rated voltage from being exceeded by transient disturbances of more than 40 when applied in Zone 2 environments
bull This equipment is not resistant to sunlight or other sources of UV radiation
bull Secure any external connections that mate to this equipment by using screws sliding latches threaded connectors or other means provided with this product
bull Do not disconnect equipment unless power has been removed or the area is known to be nonhazardous
ATTENTION Personnel responsible for the application of safety-related programmable electronic systems (PES) shall be aware of the safety requirements in the application of the system and shall be trained in using the system
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 5
North American Hazardous Location Approval
Preventing Electrostatic Discharge
The following information applies when operating this equipment in hazardous locations
Informations sur lrsquoutilisation de cet eacutequipement en environnements dangereux
Products marked CL I DIV 2 GP A B C D are suitable for use in Class I Division 2 Groups A B C D Hazardous Locations and nonhazardous locations only Each product is supplied with markings on the rating nameplate indicating the hazardous location temperature code When combining products within a system the most adverse temperature code (lowest T number) may be used to help determine the overall temperature code of the system Combinations of equipment in your system are subject to investigation by the local Authority Having Jurisdiction at the time of installation
Les produits marqueacutes CL I DIV 2 GP A B C D ne conviennent quagrave une utilisation en environnements de Classe I Division 2 Groupes A B C D dangereux et non dangereux Chaque produit est livreacute avec des marquages sur sa plaque didentification qui indiquent le code de tempeacuterature pour les environnements dangereux Lorsque plusieurs produits sont combineacutes dans un systegraveme le code de tempeacuterature le plus deacutefavorable (code de tempeacuterature le plus faible) peut ecirctre utiliseacute pour deacuteterminer le code de tempeacuterature global du systegraveme Les combinaisons deacutequipements dans le systegraveme sont sujettes agrave inspection par les autoriteacutes locales qualifieacutees au moment de linstallation
WARNING EXPLOSION HAZARD -bull Do not disconnect equipment unless
power has been removed or the area is known to be nonhazardous
bull Do not disconnect connections to this equipment unless power has been removed or the area is known to be nonhazardous Secure any external connections that mate to this equipment by using screws sliding latches threaded connectors or other means provided with this product
bull Substitution of components may impair suitability for Class I Division 2
bull If this product contains batteries they must only be changed in an area known to be nonhazardous
AVERTISSEMENT RISQUE DrsquoEXPLOSION ndash bull Couper le courant ou sassurer
que lenvironnement est classeacute non dangereux avant de deacutebrancher leacutequipement
bull Couper le courant ou sassurer que lenvironnement est classeacute non dangereux avant de deacutebrancher les connecteurs Fixer tous les connecteurs externes relieacutes agrave cet eacutequipement agrave laide de vis loquets coulissants connecteurs fileteacutes ou autres moyens fournis avec ce produit
bull La substitution de composants peut rendre cet eacutequipement inadapteacute agrave une utilisation en environnement de Classe I Division 2
bull Sassurer que lenvironnement est classeacute non dangereux avant de changer les piles
ATTENTION This equipment is sensitive to electrostatic discharge which can cause internal damage and affect normal operation Follow these guidelines when you handle this equipment
bull Touch a grounded object to discharge potential staticbull Wear an approved grounding wriststrapbull Do not touch connectors or pins on component boardsbull Do not touch circuit components inside the equipmentbull Use a static-safe workstation if availablebull Store the equipment in appropriate static-safe packaging when not in use
Publication 1768-IN004D-EN-P - December 2009
6 CompactLogix Controllers
About CompactLogix ControllersCompactLogix 1768-L43 and 1768-L45 controllers are designed to provide a Logix solution for medium-sized applications Compact GuardLogix controller catalog numbers end in lsquoSrsquo These safety controllers are wider than their standard counterparts
Verify Compatibility
This table shows the compatible RSLogix 5000 software versions and controller firmware revisions
IMPORTANT Attempting to use controllers with incompatible software and firmware revisions may result in
bull an inability to connect to the series B controller in RSLogix 5000 software
bull unsuccessful firmware upgrades in ControlFlash or AutoFlash utilities
Controllers RSLogix 5000 Software Version or Later
Controller Firmware Revision or Later
1768-L43 and 1768-L45 Series B
1603 1623
1768-L43S and 1768-L45S Series B
18 18
1768-L43 1768-L45 1768-L43S 1768-L45S
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 7
Required System ComponentsYou need these parts when installing your controller
bull 1768-L43 1768-L43S 1768-L45 or 1768-L45S CompactLogix controller
bull 1768-PA3 or 1768-PB3 power supply
bull 1769-ECR end cap
bull Mounting screws (M4 or 8 panhead) or one of these EN 50 022 DIN rails
ndash 35 x 75 mm (138 x 030 in)
ndash 35 x 15 mm (138 x 059 in)
bull 1756-CP3 serial cable (or make your own)
Clearance RequirementsAllow for the minimum clearance from enclosure walls wireways and other equipment
IMPORTANT These minimum clearances keep the modules cool enough in most situationsSee Specifications on page 32 for the acceptable temperature range
31609-M
PowerOUT
L1
L2N
90 mm(354 in)
105 mm (413 in)
90 mm(354 in)
105 mm (413 in)
Publication 1768-IN004D-EN-P - December 2009
8 CompactLogix Controllers
Module Placement
Follow these requirements to determine proper placement of your 1768 controller power supply 1768 IO modules and 1769 IO modules
bull Place the 1768-L4xx controller so that it is the last module (furthest away from the power supply) in the 1768 backplane
bull The 1768 CompactLogix power supply distributes power from the right side of the supply and must be the leftmost module in the system
bull Up to eight 1769 IO modules can reside in the local bank
bull The local bank is powered by a 1768 power supply
bull Up to two remote banks of 1769 IO modules may be connected by using 1769-CRLx extension cables
bull Remote banks are powered by a standard 1769 power supply
IMPORTANT CompactLogix System Distance RatingsBecause the 1768 CompactLogix power supply works with the controller to power a 1768 system the distance rating in a 1768 CompactLogix system differs from that in a 1769 CompactLogix systemIn the 1768 system the distance rating is the distance between 1769 IO modules and the controller In the 1769 system the distance rating is the distance between 1769 IO modules and the power supply
1768 Backplane (local) 1768 Controller Power
Supply and IO ModulesRemote Bank
1769 Power Supply andIO Modules
1769 Backplane
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 9
bull Up to eight 1769 Compact IO modules can reside on each side of a 1769 power supply in a remote bank Consult the modulersquos specifications for its distance rating
bull The type of controller determines the maximum number of 1768 modules that can reside in the local bank and the maximum number of 1769 IO modules that can reside in one local and up to two remote banks
Install the ControllerFollow these steps to install your controller
1 Mount the controller to a panel or on a DIN rail
2 Confirm the installation
3 Connect the controller
4 Configure a serial or Ethernet driver
5 Install a CompactFlash card (optional)
6 Download and install controller firmware
IMPORTANT Never place a 1769 power supply in a local bank with a 1768 controller or a major fault will occur
Controller Max Local 1768 Modules
Max 1769 IO Modules(local and remote)
1768-L43 1768-L43S 2 16
1768-L45 1768-L45S 4 30
IMPORTANT Do not use screws if using a DIN rail to mount the controller You can break the mounting tabs if you screw the controller to a panel while it is on a DIN rail
Publication 1768-IN004D-EN-P - December 2009
10 CompactLogix Controllers
Panel Mount the ControllerFollow these steps to mount your controller by using the panhead screws
1 Connect the CompactLogix modules together as shown in Mount the Controller on a DIN Rail on page 10
2 Use the controller as a template and mark pilot holes on your panel
3 Drill the pilot holes for M4 or 8 screws
4 Use M4 or 8 screws to mount the controller to your panel with 116 Nbullm (10 lbbullin) of torque
5 Ground the module on a ground bus with a dedicated earth ground stake
6 Connect the ground bus to a functional earth ground on the panel or a DIN rail
Mount the Controller on a DIN Rail
ATTENTION During mounting of all devices be sure that all debris (such as metal chips or wire strands) is kept from falling into the controller or IO modules Debris that falls into the controller or modules could cause damage while the controller is energized
ATTENTION This product is grounded through the DIN rail to chassis ground Use zinc plated yellow-chromate steel DIN rail to assure proper grounding The use of other DIN rail materials (for example aluminum and plastic) that can corrode oxidize or are poor conductors can result in improper or intermittent grounding Secure DIN rail to the mounting surface approximately every 200 mm (787 in) and use end anchors appropriately
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN ltFEFF9ad854c18cea51fa529b7528002000410064006f0062006500200050004400460020658766f8306e4f5c6210306b4f7f75283057307e30593002537052376642306e753b8cea3092670059279650306b4fdd306430533068304c3067304d307e3059300230c730b930af30c830c330d730d730ea30f330bf3067306e53705237307e305f306f30d730eb30fc30d57528306b9069305730663044307e305930023053306e8a2d5b9a30674f5c62103055308c305f0020005000440046002030d530a130a430eb306f3001004100630072006f0062006100740020304a30883073002000410064006f00620065002000520065006100640065007200200035002e003000204ee5964d3067958b304f30533068304c3067304d307e30593002gt KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB ltFEFF005500740069006c0069007a006500200065007300730061007300200063006f006e00660069006700750072006100e700f50065007300200064006500200066006f0072006d00610020006100200063007200690061007200200064006f00630075006d0065006e0074006f0073002000410064006f0062006500200050004400460020007000610072006100200069006d0070007200650073007300f5006500730020006400650020007100750061006c0069006400610064006500200065006d00200069006d00700072006500730073006f0072006100730020006400650073006b0074006f00700020006500200064006900730070006f00730069007400690076006f0073002000640065002000700072006f00760061002e0020004f007300200064006f00630075006d0065006e0074006f00730020005000440046002000630072006900610064006f007300200070006f00640065006d0020007300650072002000610062006500720074006f007300200063006f006d0020006f0020004100630072006f006200610074002000650020006f002000410064006f00620065002000520065006100640065007200200035002e0030002000650020007600650072007300f50065007300200070006f00730074006500720069006f007200650073002egt SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 5
North American Hazardous Location Approval
Preventing Electrostatic Discharge
The following information applies when operating this equipment in hazardous locations
Informations sur lrsquoutilisation de cet eacutequipement en environnements dangereux
Products marked CL I DIV 2 GP A B C D are suitable for use in Class I Division 2 Groups A B C D Hazardous Locations and nonhazardous locations only Each product is supplied with markings on the rating nameplate indicating the hazardous location temperature code When combining products within a system the most adverse temperature code (lowest T number) may be used to help determine the overall temperature code of the system Combinations of equipment in your system are subject to investigation by the local Authority Having Jurisdiction at the time of installation
Les produits marqueacutes CL I DIV 2 GP A B C D ne conviennent quagrave une utilisation en environnements de Classe I Division 2 Groupes A B C D dangereux et non dangereux Chaque produit est livreacute avec des marquages sur sa plaque didentification qui indiquent le code de tempeacuterature pour les environnements dangereux Lorsque plusieurs produits sont combineacutes dans un systegraveme le code de tempeacuterature le plus deacutefavorable (code de tempeacuterature le plus faible) peut ecirctre utiliseacute pour deacuteterminer le code de tempeacuterature global du systegraveme Les combinaisons deacutequipements dans le systegraveme sont sujettes agrave inspection par les autoriteacutes locales qualifieacutees au moment de linstallation
WARNING EXPLOSION HAZARD -bull Do not disconnect equipment unless
power has been removed or the area is known to be nonhazardous
bull Do not disconnect connections to this equipment unless power has been removed or the area is known to be nonhazardous Secure any external connections that mate to this equipment by using screws sliding latches threaded connectors or other means provided with this product
bull Substitution of components may impair suitability for Class I Division 2
bull If this product contains batteries they must only be changed in an area known to be nonhazardous
AVERTISSEMENT RISQUE DrsquoEXPLOSION ndash bull Couper le courant ou sassurer
que lenvironnement est classeacute non dangereux avant de deacutebrancher leacutequipement
bull Couper le courant ou sassurer que lenvironnement est classeacute non dangereux avant de deacutebrancher les connecteurs Fixer tous les connecteurs externes relieacutes agrave cet eacutequipement agrave laide de vis loquets coulissants connecteurs fileteacutes ou autres moyens fournis avec ce produit
bull La substitution de composants peut rendre cet eacutequipement inadapteacute agrave une utilisation en environnement de Classe I Division 2
bull Sassurer que lenvironnement est classeacute non dangereux avant de changer les piles
ATTENTION This equipment is sensitive to electrostatic discharge which can cause internal damage and affect normal operation Follow these guidelines when you handle this equipment
bull Touch a grounded object to discharge potential staticbull Wear an approved grounding wriststrapbull Do not touch connectors or pins on component boardsbull Do not touch circuit components inside the equipmentbull Use a static-safe workstation if availablebull Store the equipment in appropriate static-safe packaging when not in use
Publication 1768-IN004D-EN-P - December 2009
6 CompactLogix Controllers
About CompactLogix ControllersCompactLogix 1768-L43 and 1768-L45 controllers are designed to provide a Logix solution for medium-sized applications Compact GuardLogix controller catalog numbers end in lsquoSrsquo These safety controllers are wider than their standard counterparts
Verify Compatibility
This table shows the compatible RSLogix 5000 software versions and controller firmware revisions
IMPORTANT Attempting to use controllers with incompatible software and firmware revisions may result in
bull an inability to connect to the series B controller in RSLogix 5000 software
bull unsuccessful firmware upgrades in ControlFlash or AutoFlash utilities
Controllers RSLogix 5000 Software Version or Later
Controller Firmware Revision or Later
1768-L43 and 1768-L45 Series B
1603 1623
1768-L43S and 1768-L45S Series B
18 18
1768-L43 1768-L45 1768-L43S 1768-L45S
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 7
Required System ComponentsYou need these parts when installing your controller
bull 1768-L43 1768-L43S 1768-L45 or 1768-L45S CompactLogix controller
bull 1768-PA3 or 1768-PB3 power supply
bull 1769-ECR end cap
bull Mounting screws (M4 or 8 panhead) or one of these EN 50 022 DIN rails
ndash 35 x 75 mm (138 x 030 in)
ndash 35 x 15 mm (138 x 059 in)
bull 1756-CP3 serial cable (or make your own)
Clearance RequirementsAllow for the minimum clearance from enclosure walls wireways and other equipment
IMPORTANT These minimum clearances keep the modules cool enough in most situationsSee Specifications on page 32 for the acceptable temperature range
31609-M
PowerOUT
L1
L2N
90 mm(354 in)
105 mm (413 in)
90 mm(354 in)
105 mm (413 in)
Publication 1768-IN004D-EN-P - December 2009
8 CompactLogix Controllers
Module Placement
Follow these requirements to determine proper placement of your 1768 controller power supply 1768 IO modules and 1769 IO modules
bull Place the 1768-L4xx controller so that it is the last module (furthest away from the power supply) in the 1768 backplane
bull The 1768 CompactLogix power supply distributes power from the right side of the supply and must be the leftmost module in the system
bull Up to eight 1769 IO modules can reside in the local bank
bull The local bank is powered by a 1768 power supply
bull Up to two remote banks of 1769 IO modules may be connected by using 1769-CRLx extension cables
bull Remote banks are powered by a standard 1769 power supply
IMPORTANT CompactLogix System Distance RatingsBecause the 1768 CompactLogix power supply works with the controller to power a 1768 system the distance rating in a 1768 CompactLogix system differs from that in a 1769 CompactLogix systemIn the 1768 system the distance rating is the distance between 1769 IO modules and the controller In the 1769 system the distance rating is the distance between 1769 IO modules and the power supply
1768 Backplane (local) 1768 Controller Power
Supply and IO ModulesRemote Bank
1769 Power Supply andIO Modules
1769 Backplane
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 9
bull Up to eight 1769 Compact IO modules can reside on each side of a 1769 power supply in a remote bank Consult the modulersquos specifications for its distance rating
bull The type of controller determines the maximum number of 1768 modules that can reside in the local bank and the maximum number of 1769 IO modules that can reside in one local and up to two remote banks
Install the ControllerFollow these steps to install your controller
1 Mount the controller to a panel or on a DIN rail
2 Confirm the installation
3 Connect the controller
4 Configure a serial or Ethernet driver
5 Install a CompactFlash card (optional)
6 Download and install controller firmware
IMPORTANT Never place a 1769 power supply in a local bank with a 1768 controller or a major fault will occur
Controller Max Local 1768 Modules
Max 1769 IO Modules(local and remote)
1768-L43 1768-L43S 2 16
1768-L45 1768-L45S 4 30
IMPORTANT Do not use screws if using a DIN rail to mount the controller You can break the mounting tabs if you screw the controller to a panel while it is on a DIN rail
Publication 1768-IN004D-EN-P - December 2009
10 CompactLogix Controllers
Panel Mount the ControllerFollow these steps to mount your controller by using the panhead screws
1 Connect the CompactLogix modules together as shown in Mount the Controller on a DIN Rail on page 10
2 Use the controller as a template and mark pilot holes on your panel
3 Drill the pilot holes for M4 or 8 screws
4 Use M4 or 8 screws to mount the controller to your panel with 116 Nbullm (10 lbbullin) of torque
5 Ground the module on a ground bus with a dedicated earth ground stake
6 Connect the ground bus to a functional earth ground on the panel or a DIN rail
Mount the Controller on a DIN Rail
ATTENTION During mounting of all devices be sure that all debris (such as metal chips or wire strands) is kept from falling into the controller or IO modules Debris that falls into the controller or modules could cause damage while the controller is energized
ATTENTION This product is grounded through the DIN rail to chassis ground Use zinc plated yellow-chromate steel DIN rail to assure proper grounding The use of other DIN rail materials (for example aluminum and plastic) that can corrode oxidize or are poor conductors can result in improper or intermittent grounding Secure DIN rail to the mounting surface approximately every 200 mm (787 in) and use end anchors appropriately
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN ltFEFF9ad854c18cea51fa529b7528002000410064006f0062006500200050004400460020658766f8306e4f5c6210306b4f7f75283057307e30593002537052376642306e753b8cea3092670059279650306b4fdd306430533068304c3067304d307e3059300230c730b930af30c830c330d730d730ea30f330bf3067306e53705237307e305f306f30d730eb30fc30d57528306b9069305730663044307e305930023053306e8a2d5b9a30674f5c62103055308c305f0020005000440046002030d530a130a430eb306f3001004100630072006f0062006100740020304a30883073002000410064006f00620065002000520065006100640065007200200035002e003000204ee5964d3067958b304f30533068304c3067304d307e30593002gt KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
6 CompactLogix Controllers
About CompactLogix ControllersCompactLogix 1768-L43 and 1768-L45 controllers are designed to provide a Logix solution for medium-sized applications Compact GuardLogix controller catalog numbers end in lsquoSrsquo These safety controllers are wider than their standard counterparts
Verify Compatibility
This table shows the compatible RSLogix 5000 software versions and controller firmware revisions
IMPORTANT Attempting to use controllers with incompatible software and firmware revisions may result in
bull an inability to connect to the series B controller in RSLogix 5000 software
bull unsuccessful firmware upgrades in ControlFlash or AutoFlash utilities
Controllers RSLogix 5000 Software Version or Later
Controller Firmware Revision or Later
1768-L43 and 1768-L45 Series B
1603 1623
1768-L43S and 1768-L45S Series B
18 18
1768-L43 1768-L45 1768-L43S 1768-L45S
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 7
Required System ComponentsYou need these parts when installing your controller
bull 1768-L43 1768-L43S 1768-L45 or 1768-L45S CompactLogix controller
bull 1768-PA3 or 1768-PB3 power supply
bull 1769-ECR end cap
bull Mounting screws (M4 or 8 panhead) or one of these EN 50 022 DIN rails
ndash 35 x 75 mm (138 x 030 in)
ndash 35 x 15 mm (138 x 059 in)
bull 1756-CP3 serial cable (or make your own)
Clearance RequirementsAllow for the minimum clearance from enclosure walls wireways and other equipment
IMPORTANT These minimum clearances keep the modules cool enough in most situationsSee Specifications on page 32 for the acceptable temperature range
31609-M
PowerOUT
L1
L2N
90 mm(354 in)
105 mm (413 in)
90 mm(354 in)
105 mm (413 in)
Publication 1768-IN004D-EN-P - December 2009
8 CompactLogix Controllers
Module Placement
Follow these requirements to determine proper placement of your 1768 controller power supply 1768 IO modules and 1769 IO modules
bull Place the 1768-L4xx controller so that it is the last module (furthest away from the power supply) in the 1768 backplane
bull The 1768 CompactLogix power supply distributes power from the right side of the supply and must be the leftmost module in the system
bull Up to eight 1769 IO modules can reside in the local bank
bull The local bank is powered by a 1768 power supply
bull Up to two remote banks of 1769 IO modules may be connected by using 1769-CRLx extension cables
bull Remote banks are powered by a standard 1769 power supply
IMPORTANT CompactLogix System Distance RatingsBecause the 1768 CompactLogix power supply works with the controller to power a 1768 system the distance rating in a 1768 CompactLogix system differs from that in a 1769 CompactLogix systemIn the 1768 system the distance rating is the distance between 1769 IO modules and the controller In the 1769 system the distance rating is the distance between 1769 IO modules and the power supply
1768 Backplane (local) 1768 Controller Power
Supply and IO ModulesRemote Bank
1769 Power Supply andIO Modules
1769 Backplane
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 9
bull Up to eight 1769 Compact IO modules can reside on each side of a 1769 power supply in a remote bank Consult the modulersquos specifications for its distance rating
bull The type of controller determines the maximum number of 1768 modules that can reside in the local bank and the maximum number of 1769 IO modules that can reside in one local and up to two remote banks
Install the ControllerFollow these steps to install your controller
1 Mount the controller to a panel or on a DIN rail
2 Confirm the installation
3 Connect the controller
4 Configure a serial or Ethernet driver
5 Install a CompactFlash card (optional)
6 Download and install controller firmware
IMPORTANT Never place a 1769 power supply in a local bank with a 1768 controller or a major fault will occur
Controller Max Local 1768 Modules
Max 1769 IO Modules(local and remote)
1768-L43 1768-L43S 2 16
1768-L45 1768-L45S 4 30
IMPORTANT Do not use screws if using a DIN rail to mount the controller You can break the mounting tabs if you screw the controller to a panel while it is on a DIN rail
Publication 1768-IN004D-EN-P - December 2009
10 CompactLogix Controllers
Panel Mount the ControllerFollow these steps to mount your controller by using the panhead screws
1 Connect the CompactLogix modules together as shown in Mount the Controller on a DIN Rail on page 10
2 Use the controller as a template and mark pilot holes on your panel
3 Drill the pilot holes for M4 or 8 screws
4 Use M4 or 8 screws to mount the controller to your panel with 116 Nbullm (10 lbbullin) of torque
5 Ground the module on a ground bus with a dedicated earth ground stake
6 Connect the ground bus to a functional earth ground on the panel or a DIN rail
Mount the Controller on a DIN Rail
ATTENTION During mounting of all devices be sure that all debris (such as metal chips or wire strands) is kept from falling into the controller or IO modules Debris that falls into the controller or modules could cause damage while the controller is energized
ATTENTION This product is grounded through the DIN rail to chassis ground Use zinc plated yellow-chromate steel DIN rail to assure proper grounding The use of other DIN rail materials (for example aluminum and plastic) that can corrode oxidize or are poor conductors can result in improper or intermittent grounding Secure DIN rail to the mounting surface approximately every 200 mm (787 in) and use end anchors appropriately
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 7
Required System ComponentsYou need these parts when installing your controller
bull 1768-L43 1768-L43S 1768-L45 or 1768-L45S CompactLogix controller
bull 1768-PA3 or 1768-PB3 power supply
bull 1769-ECR end cap
bull Mounting screws (M4 or 8 panhead) or one of these EN 50 022 DIN rails
ndash 35 x 75 mm (138 x 030 in)
ndash 35 x 15 mm (138 x 059 in)
bull 1756-CP3 serial cable (or make your own)
Clearance RequirementsAllow for the minimum clearance from enclosure walls wireways and other equipment
IMPORTANT These minimum clearances keep the modules cool enough in most situationsSee Specifications on page 32 for the acceptable temperature range
31609-M
PowerOUT
L1
L2N
90 mm(354 in)
105 mm (413 in)
90 mm(354 in)
105 mm (413 in)
Publication 1768-IN004D-EN-P - December 2009
8 CompactLogix Controllers
Module Placement
Follow these requirements to determine proper placement of your 1768 controller power supply 1768 IO modules and 1769 IO modules
bull Place the 1768-L4xx controller so that it is the last module (furthest away from the power supply) in the 1768 backplane
bull The 1768 CompactLogix power supply distributes power from the right side of the supply and must be the leftmost module in the system
bull Up to eight 1769 IO modules can reside in the local bank
bull The local bank is powered by a 1768 power supply
bull Up to two remote banks of 1769 IO modules may be connected by using 1769-CRLx extension cables
bull Remote banks are powered by a standard 1769 power supply
IMPORTANT CompactLogix System Distance RatingsBecause the 1768 CompactLogix power supply works with the controller to power a 1768 system the distance rating in a 1768 CompactLogix system differs from that in a 1769 CompactLogix systemIn the 1768 system the distance rating is the distance between 1769 IO modules and the controller In the 1769 system the distance rating is the distance between 1769 IO modules and the power supply
1768 Backplane (local) 1768 Controller Power
Supply and IO ModulesRemote Bank
1769 Power Supply andIO Modules
1769 Backplane
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 9
bull Up to eight 1769 Compact IO modules can reside on each side of a 1769 power supply in a remote bank Consult the modulersquos specifications for its distance rating
bull The type of controller determines the maximum number of 1768 modules that can reside in the local bank and the maximum number of 1769 IO modules that can reside in one local and up to two remote banks
Install the ControllerFollow these steps to install your controller
1 Mount the controller to a panel or on a DIN rail
2 Confirm the installation
3 Connect the controller
4 Configure a serial or Ethernet driver
5 Install a CompactFlash card (optional)
6 Download and install controller firmware
IMPORTANT Never place a 1769 power supply in a local bank with a 1768 controller or a major fault will occur
Controller Max Local 1768 Modules
Max 1769 IO Modules(local and remote)
1768-L43 1768-L43S 2 16
1768-L45 1768-L45S 4 30
IMPORTANT Do not use screws if using a DIN rail to mount the controller You can break the mounting tabs if you screw the controller to a panel while it is on a DIN rail
Publication 1768-IN004D-EN-P - December 2009
10 CompactLogix Controllers
Panel Mount the ControllerFollow these steps to mount your controller by using the panhead screws
1 Connect the CompactLogix modules together as shown in Mount the Controller on a DIN Rail on page 10
2 Use the controller as a template and mark pilot holes on your panel
3 Drill the pilot holes for M4 or 8 screws
4 Use M4 or 8 screws to mount the controller to your panel with 116 Nbullm (10 lbbullin) of torque
5 Ground the module on a ground bus with a dedicated earth ground stake
6 Connect the ground bus to a functional earth ground on the panel or a DIN rail
Mount the Controller on a DIN Rail
ATTENTION During mounting of all devices be sure that all debris (such as metal chips or wire strands) is kept from falling into the controller or IO modules Debris that falls into the controller or modules could cause damage while the controller is energized
ATTENTION This product is grounded through the DIN rail to chassis ground Use zinc plated yellow-chromate steel DIN rail to assure proper grounding The use of other DIN rail materials (for example aluminum and plastic) that can corrode oxidize or are poor conductors can result in improper or intermittent grounding Secure DIN rail to the mounting surface approximately every 200 mm (787 in) and use end anchors appropriately
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
8 CompactLogix Controllers
Module Placement
Follow these requirements to determine proper placement of your 1768 controller power supply 1768 IO modules and 1769 IO modules
bull Place the 1768-L4xx controller so that it is the last module (furthest away from the power supply) in the 1768 backplane
bull The 1768 CompactLogix power supply distributes power from the right side of the supply and must be the leftmost module in the system
bull Up to eight 1769 IO modules can reside in the local bank
bull The local bank is powered by a 1768 power supply
bull Up to two remote banks of 1769 IO modules may be connected by using 1769-CRLx extension cables
bull Remote banks are powered by a standard 1769 power supply
IMPORTANT CompactLogix System Distance RatingsBecause the 1768 CompactLogix power supply works with the controller to power a 1768 system the distance rating in a 1768 CompactLogix system differs from that in a 1769 CompactLogix systemIn the 1768 system the distance rating is the distance between 1769 IO modules and the controller In the 1769 system the distance rating is the distance between 1769 IO modules and the power supply
1768 Backplane (local) 1768 Controller Power
Supply and IO ModulesRemote Bank
1769 Power Supply andIO Modules
1769 Backplane
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 9
bull Up to eight 1769 Compact IO modules can reside on each side of a 1769 power supply in a remote bank Consult the modulersquos specifications for its distance rating
bull The type of controller determines the maximum number of 1768 modules that can reside in the local bank and the maximum number of 1769 IO modules that can reside in one local and up to two remote banks
Install the ControllerFollow these steps to install your controller
1 Mount the controller to a panel or on a DIN rail
2 Confirm the installation
3 Connect the controller
4 Configure a serial or Ethernet driver
5 Install a CompactFlash card (optional)
6 Download and install controller firmware
IMPORTANT Never place a 1769 power supply in a local bank with a 1768 controller or a major fault will occur
Controller Max Local 1768 Modules
Max 1769 IO Modules(local and remote)
1768-L43 1768-L43S 2 16
1768-L45 1768-L45S 4 30
IMPORTANT Do not use screws if using a DIN rail to mount the controller You can break the mounting tabs if you screw the controller to a panel while it is on a DIN rail
Publication 1768-IN004D-EN-P - December 2009
10 CompactLogix Controllers
Panel Mount the ControllerFollow these steps to mount your controller by using the panhead screws
1 Connect the CompactLogix modules together as shown in Mount the Controller on a DIN Rail on page 10
2 Use the controller as a template and mark pilot holes on your panel
3 Drill the pilot holes for M4 or 8 screws
4 Use M4 or 8 screws to mount the controller to your panel with 116 Nbullm (10 lbbullin) of torque
5 Ground the module on a ground bus with a dedicated earth ground stake
6 Connect the ground bus to a functional earth ground on the panel or a DIN rail
Mount the Controller on a DIN Rail
ATTENTION During mounting of all devices be sure that all debris (such as metal chips or wire strands) is kept from falling into the controller or IO modules Debris that falls into the controller or modules could cause damage while the controller is energized
ATTENTION This product is grounded through the DIN rail to chassis ground Use zinc plated yellow-chromate steel DIN rail to assure proper grounding The use of other DIN rail materials (for example aluminum and plastic) that can corrode oxidize or are poor conductors can result in improper or intermittent grounding Secure DIN rail to the mounting surface approximately every 200 mm (787 in) and use end anchors appropriately
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 9
bull Up to eight 1769 Compact IO modules can reside on each side of a 1769 power supply in a remote bank Consult the modulersquos specifications for its distance rating
bull The type of controller determines the maximum number of 1768 modules that can reside in the local bank and the maximum number of 1769 IO modules that can reside in one local and up to two remote banks
Install the ControllerFollow these steps to install your controller
1 Mount the controller to a panel or on a DIN rail
2 Confirm the installation
3 Connect the controller
4 Configure a serial or Ethernet driver
5 Install a CompactFlash card (optional)
6 Download and install controller firmware
IMPORTANT Never place a 1769 power supply in a local bank with a 1768 controller or a major fault will occur
Controller Max Local 1768 Modules
Max 1769 IO Modules(local and remote)
1768-L43 1768-L43S 2 16
1768-L45 1768-L45S 4 30
IMPORTANT Do not use screws if using a DIN rail to mount the controller You can break the mounting tabs if you screw the controller to a panel while it is on a DIN rail
Publication 1768-IN004D-EN-P - December 2009
10 CompactLogix Controllers
Panel Mount the ControllerFollow these steps to mount your controller by using the panhead screws
1 Connect the CompactLogix modules together as shown in Mount the Controller on a DIN Rail on page 10
2 Use the controller as a template and mark pilot holes on your panel
3 Drill the pilot holes for M4 or 8 screws
4 Use M4 or 8 screws to mount the controller to your panel with 116 Nbullm (10 lbbullin) of torque
5 Ground the module on a ground bus with a dedicated earth ground stake
6 Connect the ground bus to a functional earth ground on the panel or a DIN rail
Mount the Controller on a DIN Rail
ATTENTION During mounting of all devices be sure that all debris (such as metal chips or wire strands) is kept from falling into the controller or IO modules Debris that falls into the controller or modules could cause damage while the controller is energized
ATTENTION This product is grounded through the DIN rail to chassis ground Use zinc plated yellow-chromate steel DIN rail to assure proper grounding The use of other DIN rail materials (for example aluminum and plastic) that can corrode oxidize or are poor conductors can result in improper or intermittent grounding Secure DIN rail to the mounting surface approximately every 200 mm (787 in) and use end anchors appropriately
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP ltFEFF005500740069006c0069006300650020006500730074006100200063006f006e0066006900670075007200610063006900f3006e0020007000610072006100200063007200650061007200200064006f00630075006d0065006e0074006f0073002000640065002000410064006f0062006500200050004400460020007000610072006100200063006f006e00730065006700750069007200200069006d0070007200650073006900f3006e002000640065002000630061006c006900640061006400200065006e00200069006d0070007200650073006f0072006100730020006400650020006500730063007200690074006f00720069006f00200079002000680065007200720061006d00690065006e00740061007300200064006500200063006f00720072006500630063006900f3006e002e002000530065002000700075006500640065006e00200061006200720069007200200064006f00630075006d0065006e0074006f00730020005000440046002000630072006500610064006f007300200063006f006e0020004100630072006f006200610074002c002000410064006f00620065002000520065006100640065007200200035002e003000200079002000760065007200730069006f006e0065007300200070006f00730074006500720069006f007200650073002egt FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR ltFEFF004200720075006b00200064006900730073006500200069006e006e007300740069006c006c0069006e00670065006e0065002000740069006c002000e50020006f0070007000720065007400740065002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e00740065007200200066006f00720020007500740073006b00720069006600740020006100760020006800f800790020006b00760061006c00690074006500740020007000e500200062006f007200640073006b0072006900760065007200200065006c006c00650072002000700072006f006f006600650072002e0020005000440046002d0064006f006b0075006d0065006e00740065006e00650020006b0061006e002000e50070006e00650073002000690020004100630072006f00620061007400200065006c006c00650072002000410064006f00620065002000520065006100640065007200200035002e003000200065006c006c00650072002000730065006e006500720065002egt PTB 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 SUO ltFEFF004b00e40079007400e40020006e00e40069007400e4002000610073006500740075006b007300690061002c0020006b0075006e0020006c0075006f0074002000410064006f0062006500200050004400460020002d0064006f006b0075006d0065006e007400740065006a00610020006c0061006100640075006b006100730074006100200074007900f6007000f60079007400e400740075006c006f0073007400750073007400610020006a00610020007600650064006f007300740075007300740061002000760061007200740065006e002e00200020004c0075006f0064007500740020005000440046002d0064006f006b0075006d0065006e00740069007400200076006f0069006400610061006e0020006100760061007400610020004100630072006f0062006100740069006c006c00610020006a0061002000410064006f00620065002000520065006100640065007200200035002e0030003a006c006c00610020006a006100200075007500640065006d006d0069006c006c0061002egt SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
10 CompactLogix Controllers
Panel Mount the ControllerFollow these steps to mount your controller by using the panhead screws
1 Connect the CompactLogix modules together as shown in Mount the Controller on a DIN Rail on page 10
2 Use the controller as a template and mark pilot holes on your panel
3 Drill the pilot holes for M4 or 8 screws
4 Use M4 or 8 screws to mount the controller to your panel with 116 Nbullm (10 lbbullin) of torque
5 Ground the module on a ground bus with a dedicated earth ground stake
6 Connect the ground bus to a functional earth ground on the panel or a DIN rail
Mount the Controller on a DIN Rail
ATTENTION During mounting of all devices be sure that all debris (such as metal chips or wire strands) is kept from falling into the controller or IO modules Debris that falls into the controller or modules could cause damage while the controller is energized
ATTENTION This product is grounded through the DIN rail to chassis ground Use zinc plated yellow-chromate steel DIN rail to assure proper grounding The use of other DIN rail materials (for example aluminum and plastic) that can corrode oxidize or are poor conductors can result in improper or intermittent grounding Secure DIN rail to the mounting surface approximately every 200 mm (787 in) and use end anchors appropriately
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 11
Mount 1768 Components
Follow these steps to mount the controller
1 Mount the controller on the DIN rail
2 Mount additional 1768 modules to the left of the controller
3 Mount the 1768 power supply and other 1768 modules
31595-M
a
31596 -M
b
31597-M
31598 -M
b
c
c
a
a
31599-M
Publication 1768-IN004D-EN-P - December 2009
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA ltFEFF005500740069006c006900730065007a00200063006500730020006f007000740069006f006e00730020006100660069006e00200064006500200063007200e900650072002000640065007300200064006f00630075006d0065006e00740073002000410064006f00620065002000500044004600200070006f007500720020006400650073002000e90070007200650075007600650073002000650074002000640065007300200069006d007000720065007300730069006f006e00730020006400650020006800610075007400650020007100750061006c0069007400e90020007300750072002000640065007300200069006d007000720069006d0061006e0074006500730020006400650020006200750072006500610075002e0020004c0065007300200064006f00630075006d0065006e00740073002000500044004600200063007200e900e90073002000700065007500760065006e0074002000ea0074007200650020006f007500760065007200740073002000640061006e00730020004100630072006f006200610074002c002000610069006e00730069002000710075002700410064006f00620065002000520065006100640065007200200035002e0030002000650074002000760065007200730069006f006e007300200075006c007400e90072006900650075007200650073002egt ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
12 CompactLogix Controllers
Mount 1769 IO Modules
Follow these steps to mount 1769 IO modules to the right of the controller
1 Align the upper and lower tongue-and-groove slots and slide the module back toward the DIN rail until the bus levers line up
2 Close the DIN rail latches
3 Slide the bus lever to the left to lock the modules together
ATTENTION When attaching IO modules it is very important that the bus connectors are securely locked together for proper electrical connection
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA ltFEFF005500740069006c0069007a007a006100720065002000710075006500730074006500200069006d0070006f007300740061007a0069006f006e00690020007000650072002000630072006500610072006500200064006f00630075006d0065006e00740069002000410064006f006200650020005000440046002000700065007200200075006e00610020007300740061006d007000610020006400690020007100750061006c0069007400e00020007300750020007300740061006d00700061006e0074006900200065002000700072006f006f0066006500720020006400650073006b0074006f0070002e0020004900200064006f00630075006d0065006e007400690020005000440046002000630072006500610074006900200070006f00730073006f006e006f0020006500730073006500720065002000610070006500720074006900200063006f006e0020004100630072006f00620061007400200065002000410064006f00620065002000520065006100640065007200200035002e003000200065002000760065007200730069006f006e006900200073007500630063006500730073006900760065002egt JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 13
4 Attach the end cap by using the tongue and groove slots (a) and locking the bus lever (b)
Confirm the InstallationAfter you have installed the controller and applied power check that the PWR and IO PWR status indicators are solid green
If the indicators are in any other state see Troubleshoot System Power on page 28
a
b
a
PowerOUT
L1
L2N
Publication 1768-IN004D-EN-P - December 2009
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN ltFEFF004200720075006700200069006e0064007300740069006c006c0069006e006700650072006e0065002000740069006c0020006100740020006f007000720065007400740065002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e007400650072002000740069006c0020006b00760061006c00690074006500740073007500640073006b007200690076006e0069006e006700200065006c006c006500720020006b006f007200720065006b007400750072006c00e60073006e0069006e0067002e0020004400650020006f007000720065007400740065006400650020005000440046002d0064006f006b0075006d0065006e0074006500720020006b0061006e002000e50062006e00650073002000690020004100630072006f00620061007400200065006c006c006500720020004100630072006f006200610074002000520065006100640065007200200035002e00300020006f00670020006e0079006500720065002egt DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
14 CompactLogix Controllers
Connect to the Controller
Connect the 1756-CP3 serial cable to the controllerrsquos serial port and to your workstation
If you make your own cable follow these guidelines
bull Wire the connectors as shown
bull Limit the cable length to 152 m (50 ft)
bull Attach the shield to both connectors
Configure a Communication DriverBefore you update controller firmware or use the controller in your network you must configure a communication driver specific to your network
See Configure a Serial Driver on page 15 or Configure an EtherNetIP Driver on page 17
WARNING If you connect or disconnect the serial cable with power applied to this module or the serial device on the other end of the cable an electrical arc can occur This could cause an explosion in hazardous location installations
Be sure that power is removed or the area is nonhazardous before proceeding
Workstation Controller
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
1 DCD2 RDX3 TXD4 DTR
COMMON6 DSR7 RTS8 CTS9
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN ltFEFF004200720075006700200069006e0064007300740069006c006c0069006e006700650072006e0065002000740069006c0020006100740020006f007000720065007400740065002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e007400650072002000740069006c0020006b00760061006c00690074006500740073007500640073006b007200690076006e0069006e006700200065006c006c006500720020006b006f007200720065006b007400750072006c00e60073006e0069006e0067002e0020004400650020006f007000720065007400740065006400650020005000440046002d0064006f006b0075006d0065006e0074006500720020006b0061006e002000e50062006e00650073002000690020004100630072006f00620061007400200065006c006c006500720020004100630072006f006200610074002000520065006100640065007200200035002e00300020006f00670020006e0079006500720065002egt DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB ltFEFF005500740069006c0069007a006500200065007300730061007300200063006f006e00660069006700750072006100e700f50065007300200064006500200066006f0072006d00610020006100200063007200690061007200200064006f00630075006d0065006e0074006f0073002000410064006f0062006500200050004400460020007000610072006100200069006d0070007200650073007300f5006500730020006400650020007100750061006c0069006400610064006500200065006d00200069006d00700072006500730073006f0072006100730020006400650073006b0074006f00700020006500200064006900730070006f00730069007400690076006f0073002000640065002000700072006f00760061002e0020004f007300200064006f00630075006d0065006e0074006f00730020005000440046002000630072006900610064006f007300200070006f00640065006d0020007300650072002000610062006500720074006f007300200063006f006d0020006f0020004100630072006f006200610074002000650020006f002000410064006f00620065002000520065006100640065007200200035002e0030002000650020007600650072007300f50065007300200070006f00730074006500720069006f007200650073002egt SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 15
Configure a Serial Driver
Use RSLinx software to configure the driver for serial communication
1 From the Communications menu choose Configure Drivers
2 From the Available Driver Types pull-down menu choose the RS-232 DF1 devices driver
3 Click Add New
4 Type a name for the driver and click OK
Publication 1768-IN004D-EN-P - December 2009
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA ltFEFF005500740069006c0069007a007a006100720065002000710075006500730074006500200069006d0070006f007300740061007a0069006f006e00690020007000650072002000630072006500610072006500200064006f00630075006d0065006e00740069002000410064006f006200650020005000440046002000700065007200200075006e00610020007300740061006d007000610020006400690020007100750061006c0069007400e00020007300750020007300740061006d00700061006e0074006900200065002000700072006f006f0066006500720020006400650073006b0074006f0070002e0020004900200064006f00630075006d0065006e007400690020005000440046002000630072006500610074006900200070006f00730073006f006e006f0020006500730073006500720065002000610070006500720074006900200063006f006e0020004100630072006f00620061007400200065002000410064006f00620065002000520065006100640065007200200035002e003000200065002000760065007200730069006f006e006900200073007500630063006500730073006900760065002egt JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
16 CompactLogix Controllers
5 From the Comm Port pull-down menu on the Configure Devices dialog box choose the serial port on the workstation
to which your cable is connected
6 From the Device pull-down menu choose Logix5550CompactLogix
7 Click Auto-Configure
a Click OK if the Auto Configuration Successful dialog box appears
b If the dialog box does not appear go back to step 5 and verify that you selected the correct comm port
8 Click Close
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR ltFEFF004200720075006b00200064006900730073006500200069006e006e007300740069006c006c0069006e00670065006e0065002000740069006c002000e50020006f0070007000720065007400740065002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e00740065007200200066006f00720020007500740073006b00720069006600740020006100760020006800f800790020006b00760061006c00690074006500740020007000e500200062006f007200640073006b0072006900760065007200200065006c006c00650072002000700072006f006f006600650072002e0020005000440046002d0064006f006b0075006d0065006e00740065006e00650020006b0061006e002000e50070006e00650073002000690020004100630072006f00620061007400200065006c006c00650072002000410064006f00620065002000520065006100640065007200200035002e003000200065006c006c00650072002000730065006e006500720065002egt PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 17
Configure an EtherNetIP Driver
For EtherNetIP communication you must use a 1768-ENBT or 1768-EWEB module If your controller is a 1768-L4xS you must use a series B 1768-ENBT or 1768-EWEB module You can install up to two of these modules to the left of the controller in the 1768 backplane Before you can load controller firmware via the EtherNetIP network you must set the EtherNetIP modulersquos IP address You can set the IP address by using the BootP-DHCP Utility on the Tools menu in RSLogix 5000 software
For more information refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Set the Communication Path to the Controller
1 Open an RSLogix 5000 project for the controller
2 From the Communications menu choose Who Active
3 Expand the communication driver to the level of the controller
4 Select the controller
5 Complete the desired action
To Click
Monitor the project in the controller Go Online
Transfer a copy of the project from the controller to RSLogix 5000 software Upload
Transfer the open project to the controller Download
Publication 1768-IN004D-EN-P - December 2009
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
18 CompactLogix Controllers
Insert or Remove a CompactFlash Card
Follow these steps to insert or remove a CompactFlash card
1 Press the memory-card door latch on the controller front panel and pivot the door down toward you
2 Insert or remove the card from the slot
3 Close the memory card door
Install Controller FirmwareThe controller ships without functioning firmware so you must obtain and install the firmware before you can use your controller
Firmware revisions are available with RSLogix 5000 programming software or you can download them from the support website athttpsupportrockwellautomationcom Be prepared to enter the serial number of your RSLogix 5000 software
To install firmware you can use any of the following
WARNING When you insert or remove the CompactFlash card while power is on an electrical arc can occur This could cause an explosion in hazardous location installationsBe sure that power is removed or the area is nonhazardous before proceeding
IMPORTANT When installing or updating controller firmware do not interrupt the update process in any way Interrupting the firmware update may result in an inoperable controllerInoperable controllers must be returned to Rockwell Automation
Method Page
ControlFlash version 8 or later software that ships with RSLogix 5000 software 19
AutoFlash software that runs within RSLogix 5000 software 20
A 1784-CF64 or 1784-CF128 CompactFlash card with valid firmware already loaded 21
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN ltFEFF9ad854c18cea51fa529b7528002000410064006f0062006500200050004400460020658766f8306e4f5c6210306b4f7f75283057307e30593002537052376642306e753b8cea3092670059279650306b4fdd306430533068304c3067304d307e3059300230c730b930af30c830c330d730d730ea30f330bf3067306e53705237307e305f306f30d730eb30fc30d57528306b9069305730663044307e305930023053306e8a2d5b9a30674f5c62103055308c305f0020005000440046002030d530a130a430eb306f3001004100630072006f0062006100740020304a30883073002000410064006f00620065002000520065006100640065007200200035002e003000204ee5964d3067958b304f30533068304c3067304d307e30593002gt KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE ltFEFF0041006e007600e4006e00640020006400650020006800e4007200200069006e0073007400e4006c006c006e0069006e006700610072006e00610020006f006d002000640075002000760069006c006c00200073006b006100700061002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e00740020006600f600720020006b00760061006c00690074006500740073007500740073006b0072006900660074006500720020007000e5002000760061006e006c00690067006100200073006b0072006900760061007200650020006f006300680020006600f600720020006b006f007200720065006b007400750072002e002000200053006b006100700061006400650020005000440046002d0064006f006b0075006d0065006e00740020006b0061006e002000f600700070006e00610073002000690020004100630072006f0062006100740020006f00630068002000410064006f00620065002000520065006100640065007200200035002e00300020006f00630068002000730065006e006100720065002egt ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 19
Updating your controller firmware via ControlFlash or AutoFlash software requires either a serial or other network connection to the controller
Updating via an Ethernet connection is faster but you must first install a 1768-ENBT Ethernet module to connect to the controller via the Ethernet network
For information on installing configuring and operating a 1768-ENBT module refer to the EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Install Firmware via ControlFlash Software
1 Make sure the network is connected
2 Start ControlFlash software
3 When the Welcome dialog box appears click Next
4 Select the catalog number of the controller and click Next
5 Expand the network until you see the controller
6 Select the controller and click OK
7 Select the desired revision level and click Next
8 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
9 Click OK
10 Click Cancel and then Yes to close ControlFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
20 CompactLogix Controllers
Install Firmware via AutoFlash Software
1 Make sure the network is connected
2 Using RSLogix 5000 software attempt a download to a controller project
AutoFlash software launches if the required firmware is not loaded on the controller
3 Select the catalog number of the controller and click Next
4 Expand the network until you see the controller
5 Select the controller and click OK
6 Select the desired revision level and click Next
7 To start the update click Finish and then Yes
The OK status indicator flashes red to show that the update is in progress The status box indicates when the update is complete and the OK status indicator is solid green
8 Click OK
9 Click Cancel and then Yes to close AutoFlash software
TIP If the required network is not shown first configure a driver for that network in RSLinx software
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA ltFEFF005500740069006c0069007a007a006100720065002000710075006500730074006500200069006d0070006f007300740061007a0069006f006e00690020007000650072002000630072006500610072006500200064006f00630075006d0065006e00740069002000410064006f006200650020005000440046002000700065007200200075006e00610020007300740061006d007000610020006400690020007100750061006c0069007400e00020007300750020007300740061006d00700061006e0074006900200065002000700072006f006f0066006500720020006400650073006b0074006f0070002e0020004900200064006f00630075006d0065006e007400690020005000440046002000630072006500610074006900200070006f00730073006f006e006f0020006500730073006500720065002000610070006500720074006900200063006f006e0020004100630072006f00620061007400200065002000410064006f00620065002000520065006100640065007200200035002e003000200065002000760065007200730069006f006e006900200073007500630063006500730073006900760065002egt JPN ltFEFF9ad854c18cea51fa529b7528002000410064006f0062006500200050004400460020658766f8306e4f5c6210306b4f7f75283057307e30593002537052376642306e753b8cea3092670059279650306b4fdd306430533068304c3067304d307e3059300230c730b930af30c830c330d730d730ea30f330bf3067306e53705237307e305f306f30d730eb30fc30d57528306b9069305730663044307e305930023053306e8a2d5b9a30674f5c62103055308c305f0020005000440046002030d530a130a430eb306f3001004100630072006f0062006100740020304a30883073002000410064006f00620065002000520065006100640065007200200035002e003000204ee5964d3067958b304f30533068304c3067304d307e30593002gt KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 21
Install Firmware via a CompactFlash Card
Follow these steps to use RSLogix 5000 software to store the controller program and firmware of an already-configured controller to the CompactFlash card The firmware is automatically stored on your CompactFlash card when you store the program
1 With the CompactFlash card installed on the configured controller on the Controller Properties dialog box click the Nonvolatile Memory tab
2 Click Load Image On Powerup to save to the card
3 Remove the card and insert it into the controller onto which you want to load the firmware and user program
4 Start the new controller and the image stored on the CompactFlash card loads
Remove a 1768 or 1769 Module from the DIN RailIf you need to remove a module from the DIN rail follow these steps
1 Remove power from the controller and wait for all status indicators on the power supply and controller to turn off
IMPORTANT If you disconnect any part of the system while the controller is still writing its program to memory you will lose your program
PowerOUT
L1
L2N
Off
Publication 1768-IN004D-EN-P - December 2009
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA ltFEFF005500740069006c006900730065007a00200063006500730020006f007000740069006f006e00730020006100660069006e00200064006500200063007200e900650072002000640065007300200064006f00630075006d0065006e00740073002000410064006f00620065002000500044004600200070006f007500720020006400650073002000e90070007200650075007600650073002000650074002000640065007300200069006d007000720065007300730069006f006e00730020006400650020006800610075007400650020007100750061006c0069007400e90020007300750072002000640065007300200069006d007000720069006d0061006e0074006500730020006400650020006200750072006500610075002e0020004c0065007300200064006f00630075006d0065006e00740073002000500044004600200063007200e900e90073002000700065007500760065006e0074002000ea0074007200650020006f007500760065007200740073002000640061006e00730020004100630072006f006200610074002c002000610069006e00730069002000710075002700410064006f00620065002000520065006100640065007200200035002e0030002000650074002000760065007200730069006f006e007300200075006c007400e90072006900650075007200650073002egt ITA ltFEFF005500740069006c0069007a007a006100720065002000710075006500730074006500200069006d0070006f007300740061007a0069006f006e00690020007000650072002000630072006500610072006500200064006f00630075006d0065006e00740069002000410064006f006200650020005000440046002000700065007200200075006e00610020007300740061006d007000610020006400690020007100750061006c0069007400e00020007300750020007300740061006d00700061006e0074006900200065002000700072006f006f0066006500720020006400650073006b0074006f0070002e0020004900200064006f00630075006d0065006e007400690020005000440046002000630072006500610074006900200070006f00730073006f006e006f0020006500730073006500720065002000610070006500720074006900200063006f006e0020004100630072006f00620061007400200065002000410064006f00620065002000520065006100640065007200200035002e003000200065002000760065007200730069006f006e006900200073007500630063006500730073006900760065002egt JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
22 CompactLogix Controllers
2 Remove the 1768 module
3 Remove the 1769 module by unlocking the bus lever (a) and DIN rail latches (b)
4 Slide the module away from the DIN rail along the tongue and groove slots
PowerOUT
L1
L2N
a b
a
31607-M
PowerO U T
L 1
L 2 N
c d
c
PowerOUT
L1
L2N
b a
b
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN ltFEFF004200720075006700200069006e0064007300740069006c006c0069006e006700650072006e0065002000740069006c0020006100740020006f007000720065007400740065002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e007400650072002000740069006c0020006b00760061006c00690074006500740073007500640073006b007200690076006e0069006e006700200065006c006c006500720020006b006f007200720065006b007400750072006c00e60073006e0069006e0067002e0020004400650020006f007000720065007400740065006400650020005000440046002d0064006f006b0075006d0065006e0074006500720020006b0061006e002000e50062006e00650073002000690020004100630072006f00620061007400200065006c006c006500720020004100630072006f006200610074002000520065006100640065007200200035002e00300020006f00670020006e0079006500720065002egt DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 23
Status Indicators
Controller Status Indicators
Indicator State Description
PWRGreen The controller is providing power to 1768 modules in
the system
Off or red See Troubleshoot System Power on page 28
IO PWR
Off Replace the controller
Green The controller is operating properly
Flashing redgreen or solid red
See Troubleshoot System Power on page 28
RUNOff The controller is in PROG or Test mode
Green The controller is in RUN mode
FORCE
Off No tags contain IO force values or IO forces are inactive (disabled)
Amber IO forces are active (enabled) IO force values may or may not exist
Flashing amber One or more input or output addresses have been forced to an On or Off state but the forces have not been enabled Enable forces or remove the individual IO from being forced
MEM SAVE
Off The user program and configuration data are not actively being saved to flash memory
Green The use program and configuration data are being saved to flash memory
IO Off There are no devices in the IO configuration of the controller or the controller does not contain a project
Green The controller is communicating with all of the devices in its IO configuration
Flashing green One or more devices in the controllerrsquos IO configuration are not respondingSee Troubleshoot a Nonresponsive Module on page 27
Flashing red The controller is not communicating with any of the devices in its IO configurationSee Troubleshoot a Nonresponsive Module on page 27
Publication 1768-IN004D-EN-P - December 2009
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR ltFEFF004200720075006b00200064006900730073006500200069006e006e007300740069006c006c0069006e00670065006e0065002000740069006c002000e50020006f0070007000720065007400740065002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e00740065007200200066006f00720020007500740073006b00720069006600740020006100760020006800f800790020006b00760061006c00690074006500740020007000e500200062006f007200640073006b0072006900760065007200200065006c006c00650072002000700072006f006f006600650072002e0020005000440046002d0064006f006b0075006d0065006e00740065006e00650020006b0061006e002000e50070006e00650073002000690020004100630072006f00620061007400200065006c006c00650072002000410064006f00620065002000520065006100640065007200200035002e003000200065006c006c00650072002000730065006e006500720065002egt PTB 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 SUO ltFEFF004b00e40079007400e40020006e00e40069007400e4002000610073006500740075006b007300690061002c0020006b0075006e0020006c0075006f0074002000410064006f0062006500200050004400460020002d0064006f006b0075006d0065006e007400740065006a00610020006c0061006100640075006b006100730074006100200074007900f6007000f60079007400e400740075006c006f0073007400750073007400610020006a00610020007600650064006f007300740075007300740061002000760061007200740065006e002e00200020004c0075006f0064007500740020005000440046002d0064006f006b0075006d0065006e00740069007400200076006f0069006400610061006e0020006100760061007400610020004100630072006f0062006100740069006c006c00610020006a0061002000410064006f00620065002000520065006100640065007200200035002e0030003a006c006c00610020006a006100200075007500640065006d006d0069006c006c0061002egt SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
24 CompactLogix Controllers
OK Off No power is applied If MEM SAVE indicator is green the user program and configuration data are being saved to flash memory
Flashing red bull The controller requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the controller
bull A nonrecoverable major fault occurred on the controller
bull See Clear a Major Fault on page 26
Red The controller detected a nonrecoverable major fault so it cleared the project from memorySee Clear a Nonrecoverable Fault on page 27
Green Controller is OK
Flashing green The controller is storing or loading a project to or from nonvolatile memory
CF Off There is no CompactFlash card activity
Flashing green The controller is reading from or writing to the CompactFlash card
IMPORTANT Do not remove the CompactFlash card while the controller is reading from or writing to the card Removing the card during a read or write could corrupt data on the card data in the controller and firmware installed on the controller
Flashing red The CompactFlash card does not have a valid file system and must be replaced
DCH0 Off Channel 0 is configured differently than the default serial configuration
Green Channel 0 has the default serial configuration
CH0 Off No RS-232 activity
Green RS-232 activity
Controller Status Indicators
Indicator State Description
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 25
Safety Status Indicators (1768-L43S and 1768-L45S Controllers only)
Indicator State Description
SAFE RUN
Off The user safety task or safety outputs are disabled The controller is in PROG mode Test mode or the safety task is faulted
Green The user safety task and safety outputs are enabled The safety task is executing Safety signature is present
Flashing green The user safety task and safety outputs are enabled The safety task is executing Safety signature is not present
SAFETY TASK
Off No partnership established
Green Safety controller status is OK The coordinated system time (CST) is synchronized and safety IO connections are established
Flashing green Safety controller status is OK The coordinated system time (CST) is not synchronized
Red Safety partnership was lost
Flashing red Safety task is inoperable
SAFETY LOCK
Off Safety task is not locked
Green Safety task is locked
SAFETY OK
Off No power is applied
Green The safety partner is OK
Flashing green The safety partner is storing or loading a project to or from nonvolatile memory
Red The safety partner detected a nonrecoverable major fault so it cleared the project from its memory
Flashing red bull The internal safety partner requires a firmware update or a firmware update is in progress
bull A recoverable major fault occurred on the safety partner
bull A nonrecoverable major fault occurred on the safety partner
Publication 1768-IN004D-EN-P - December 2009
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN ltFEFF004200720075006700200069006e0064007300740069006c006c0069006e006700650072006e0065002000740069006c0020006100740020006f007000720065007400740065002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e007400650072002000740069006c0020006b00760061006c00690074006500740073007500640073006b007200690076006e0069006e006700200065006c006c006500720020006b006f007200720065006b007400750072006c00e60073006e0069006e0067002e0020004400650020006f007000720065007400740065006400650020005000440046002d0064006f006b0075006d0065006e0074006500720020006b0061006e002000e50062006e00650073002000690020004100630072006f00620061007400200065006c006c006500720020004100630072006f006200610074002000520065006100640065007200200035002e00300020006f00670020006e0079006500720065002egt DEU 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 ESP ltFEFF005500740069006c0069006300650020006500730074006100200063006f006e0066006900670075007200610063006900f3006e0020007000610072006100200063007200650061007200200064006f00630075006d0065006e0074006f0073002000640065002000410064006f0062006500200050004400460020007000610072006100200063006f006e00730065006700750069007200200069006d0070007200650073006900f3006e002000640065002000630061006c006900640061006400200065006e00200069006d0070007200650073006f0072006100730020006400650020006500730063007200690074006f00720069006f00200079002000680065007200720061006d00690065006e00740061007300200064006500200063006f00720072006500630063006900f3006e002e002000530065002000700075006500640065006e00200061006200720069007200200064006f00630075006d0065006e0074006f00730020005000440046002000630072006500610064006f007300200063006f006e0020004100630072006f006200610074002c002000410064006f00620065002000520065006100640065007200200035002e003000200079002000760065007200730069006f006e0065007300200070006f00730074006500720069006f007200650073002egt FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
26 CompactLogix Controllers
Clear a Major FaultIf the OK status indicator flashes red because of a recoverable major fault clear the fault by following these steps
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 software
3 On the Controller Properties dialog box click the Major Faults tab to find information about the fault
If the OK status indicator is flashing red because of a nonrecoverable major fault the controller
bull initially displayed a solid red OK indicator
bull reset itself
bull cleared the project from its memory
bull set the OK indicator to flashing red
bull produced a major recoverable fault and generated a corresponding fault code in the RSLogix 5000 project
ndash Fault code 60 means the CompactFlash card is not installed
ndash Fault code 61 means the CompactFlash card is installed
Follow these steps to recover from fault code 60 or 61
1 Turn the controller keyswitch from PROG to RUN and back to PROG
2 Go online with RSLogix 5000 and download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP ltFEFF005500740069006c0069006300650020006500730074006100200063006f006e0066006900670075007200610063006900f3006e0020007000610072006100200063007200650061007200200064006f00630075006d0065006e0074006f0073002000640065002000410064006f0062006500200050004400460020007000610072006100200063006f006e00730065006700750069007200200069006d0070007200650073006900f3006e002000640065002000630061006c006900640061006400200065006e00200069006d0070007200650073006f0072006100730020006400650020006500730063007200690074006f00720069006f00200079002000680065007200720061006d00690065006e00740061007300200064006500200063006f00720072006500630063006900f3006e002e002000530065002000700075006500640065006e00200061006200720069007200200064006f00630075006d0065006e0074006f00730020005000440046002000630072006500610064006f007300200063006f006e0020004100630072006f006200610074002c002000410064006f00620065002000520065006100640065007200200035002e003000200079002000760065007200730069006f006e0065007300200070006f00730074006500720069006f007200650073002egt FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 27
Clear a Nonrecoverable FaultIf the OK status indicator is solid red follow these steps to clear the fault
1 Cycle power
2 Download the project
3 Change to REM RUN or RUN mode
If the issue persists record the status of the OK and RS-232 indicators before cycling power and contacting Rockwell Automation support
Troubleshoot a Nonresponsive ModuleFollow these steps to determine why a device may not be responding
1 Verify that all IO modules in your project are installed in the same order
2 Verify that all devices have been updated to the latest major and minor firmware revisions
3 Use RSLogix 5000 softwarersquos online help to determine which module is not responding
Publication 1768-IN004D-EN-P - December 2009
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE ltFEFF0041006e007600e4006e00640020006400650020006800e4007200200069006e0073007400e4006c006c006e0069006e006700610072006e00610020006f006d002000640075002000760069006c006c00200073006b006100700061002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e00740020006600f600720020006b00760061006c00690074006500740073007500740073006b0072006900660074006500720020007000e5002000760061006e006c00690067006100200073006b0072006900760061007200650020006f006300680020006600f600720020006b006f007200720065006b007400750072002e002000200053006b006100700061006400650020005000440046002d0064006f006b0075006d0065006e00740020006b0061006e002000f600700070006e00610073002000690020004100630072006f0062006100740020006f00630068002000410064006f00620065002000520065006100640065007200200035002e00300020006f00630068002000730065006e006100720065002egt ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
28 CompactLogix Controllers
Troubleshoot System PowerThe CompactLogix power supply works with the CompactLogix controller to provide power to the system You must consider both when attempting to troubleshoot system power
To troubleshoot system power issues use the CompactLogix power supply PWR status indicator and the CompactLogix controller PWR and IO PWR indicators If the power supply is not operating properly the controller will not operate properly either You must first diagnose and correct any issues with the power supply before troubleshooting the controller
1 Examine the power supply PWR status indicator
2 If the power supply is operating properly and the power supply PWR status indicator is green examine the controller PWR indicator
3 If the controller PWR status indicator is green examine the IO PWR status indicator
IMPORTANT Before you disconnect reconnect or replace any component make sure you have turned off power and allowed all system status indicators to turn off
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA ltFEFF005500740069006c006900730065007a00200063006500730020006f007000740069006f006e00730020006100660069006e00200064006500200063007200e900650072002000640065007300200064006f00630075006d0065006e00740073002000410064006f00620065002000500044004600200070006f007500720020006400650073002000e90070007200650075007600650073002000650074002000640065007300200069006d007000720065007300730069006f006e00730020006400650020006800610075007400650020007100750061006c0069007400e90020007300750072002000640065007300200069006d007000720069006d0061006e0074006500730020006400650020006200750072006500610075002e0020004c0065007300200064006f00630075006d0065006e00740073002000500044004600200063007200e900e90073002000700065007500760065006e0074002000ea0074007200650020006f007500760065007200740073002000640061006e00730020004100630072006f006200610074002c002000610069006e00730069002000710075002700410064006f00620065002000520065006100640065007200200035002e0030002000650074002000760065007200730069006f006e007300200075006c007400e90072006900650075007200650073002egt ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 29
Examine the Power Supply PWR Status Indicator
1 Remove power and wait for all status indicators to turn off
2 Disconnect all modules from the system including the controller
3 Reapply power
4 Check the PWR status indicator on the power supply
a If the status indicator remains red replace the power supply
b If the status indicator is green one of the other modules in the system is causing the red indicator
5 Remove power and wait for all status indicators to turn off
6 Reinstall the controller and check the power supplyrsquos PWR indicator
a If green remove power wait for all status indicators to turn off and reinstall 1768 modules one at a time until you identify the module causing the red indicator
b If red replace the controller
Power Supply PWR Indicator Status
Recommended Action
Off Verify that the power supply is turned on and that adequate input power is properly connectedReplace the power supply
Green The power supply is operating properlyCheck the controller PWR and IO PWR status indicators to make sure the entire system is operating properly
Red The power supply is not producing valid 24V power to the 1768 modules Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN ltFEFF004200720075006700200069006e0064007300740069006c006c0069006e006700650072006e0065002000740069006c0020006100740020006f007000720065007400740065002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e007400650072002000740069006c0020006b00760061006c00690074006500740073007500640073006b007200690076006e0069006e006700200065006c006c006500720020006b006f007200720065006b007400750072006c00e60073006e0069006e0067002e0020004400650020006f007000720065007400740065006400650020005000440046002d0064006f006b0075006d0065006e0074006500720020006b0061006e002000e50062006e00650073002000690020004100630072006f00620061007400200065006c006c006500720020004100630072006f006200610074002000520065006100640065007200200035002e00300020006f00670020006e0079006500720065002egt DEU ltFEFF00560065007200770065006e00640065006e0020005300690065002000640069006500730065002000450069006e007300740065006c006c0075006e00670065006e0020007a0075006d002000450072007300740065006c006c0065006e00200076006f006e002000410064006f006200650020005000440046002d0044006f006b0075006d0065006e00740065006e002c00200076006f006e002000640065006e0065006e002000530069006500200068006f00630068007700650072007400690067006500200044007200750063006b006500200061007500660020004400650073006b0074006f0070002d0044007200750063006b00650072006e00200075006e0064002000500072006f006f0066002d00470065007200e400740065006e002000650072007a0065007500670065006e0020006d00f60063006800740065006e002e002000450072007300740065006c006c007400650020005000440046002d0044006f006b0075006d0065006e007400650020006b00f6006e006e0065006e0020006d006900740020004100630072006f00620061007400200075006e0064002000410064006f00620065002000520065006100640065007200200035002e00300020006f0064006500720020006800f600680065007200200067006500f600660066006e00650074002000770065007200640065006e002egt ESP ltFEFF005500740069006c0069006300650020006500730074006100200063006f006e0066006900670075007200610063006900f3006e0020007000610072006100200063007200650061007200200064006f00630075006d0065006e0074006f0073002000640065002000410064006f0062006500200050004400460020007000610072006100200063006f006e00730065006700750069007200200069006d0070007200650073006900f3006e002000640065002000630061006c006900640061006400200065006e00200069006d0070007200650073006f0072006100730020006400650020006500730063007200690074006f00720069006f00200079002000680065007200720061006d00690065006e00740061007300200064006500200063006f00720072006500630063006900f3006e002e002000530065002000700075006500640065006e00200061006200720069007200200064006f00630075006d0065006e0074006f00730020005000440046002000630072006500610064006f007300200063006f006e0020004100630072006f006200610074002c002000410064006f00620065002000520065006100640065007200200035002e003000200079002000760065007200730069006f006e0065007300200070006f00730074006500720069006f007200650073002egt FRA ltFEFF005500740069006c006900730065007a00200063006500730020006f007000740069006f006e00730020006100660069006e00200064006500200063007200e900650072002000640065007300200064006f00630075006d0065006e00740073002000410064006f00620065002000500044004600200070006f007500720020006400650073002000e90070007200650075007600650073002000650074002000640065007300200069006d007000720065007300730069006f006e00730020006400650020006800610075007400650020007100750061006c0069007400e90020007300750072002000640065007300200069006d007000720069006d0061006e0074006500730020006400650020006200750072006500610075002e0020004c0065007300200064006f00630075006d0065006e00740073002000500044004600200063007200e900e90073002000700065007500760065006e0074002000ea0074007200650020006f007500760065007200740073002000640061006e00730020004100630072006f006200610074002c002000610069006e00730069002000710075002700410064006f00620065002000520065006100640065007200200035002e0030002000650074002000760065007200730069006f006e007300200075006c007400e90072006900650075007200650073002egt ITA ltFEFF005500740069006c0069007a007a006100720065002000710075006500730074006500200069006d0070006f007300740061007a0069006f006e00690020007000650072002000630072006500610072006500200064006f00630075006d0065006e00740069002000410064006f006200650020005000440046002000700065007200200075006e00610020007300740061006d007000610020006400690020007100750061006c0069007400e00020007300750020007300740061006d00700061006e0074006900200065002000700072006f006f0066006500720020006400650073006b0074006f0070002e0020004900200064006f00630075006d0065006e007400690020005000440046002000630072006500610074006900200070006f00730073006f006e006f0020006500730073006500720065002000610070006500720074006900200063006f006e0020004100630072006f00620061007400200065002000410064006f00620065002000520065006100640065007200200035002e003000200065002000760065007200730069006f006e006900200073007500630063006500730073006900760065002egt JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB ltFEFF005500740069006c0069007a006500200065007300730061007300200063006f006e00660069006700750072006100e700f50065007300200064006500200066006f0072006d00610020006100200063007200690061007200200064006f00630075006d0065006e0074006f0073002000410064006f0062006500200050004400460020007000610072006100200069006d0070007200650073007300f5006500730020006400650020007100750061006c0069006400610064006500200065006d00200069006d00700072006500730073006f0072006100730020006400650073006b0074006f00700020006500200064006900730070006f00730069007400690076006f0073002000640065002000700072006f00760061002e0020004f007300200064006f00630075006d0065006e0074006f00730020005000440046002000630072006900610064006f007300200070006f00640065006d0020007300650072002000610062006500720074006f007300200063006f006d0020006f0020004100630072006f006200610074002000650020006f002000410064006f00620065002000520065006100640065007200200035002e0030002000650020007600650072007300f50065007300200070006f00730074006500720069006f007200650073002egt SUO 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 SVE ltFEFF0041006e007600e4006e00640020006400650020006800e4007200200069006e0073007400e4006c006c006e0069006e006700610072006e00610020006f006d002000640075002000760069006c006c00200073006b006100700061002000410064006f006200650020005000440046002d0064006f006b0075006d0065006e00740020006600f600720020006b00760061006c00690074006500740073007500740073006b0072006900660074006500720020007000e5002000760061006e006c00690067006100200073006b0072006900760061007200650020006f006300680020006600f600720020006b006f007200720065006b007400750072002e002000200053006b006100700061006400650020005000440046002d0064006f006b0075006d0065006e00740020006b0061006e002000f600700070006e00610073002000690020004100630072006f0062006100740020006f00630068002000410064006f00620065002000520065006100640065007200200035002e00300020006f00630068002000730065006e006100720065002egt ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
30 CompactLogix Controllers
Examine the Controller PWR Indicator
This task assumes that the power supply PWR indicator is green
1 Remove power and wait for all status indicators to turn off
2 Disconnect all 1768 modules from the system except for the controller
3 Reapply power
4 Check the controller PWR indicator
a If the status indicator remains red replace the controller
b If the status indicator is green one of the 1768 modules is causing the red indicator
5 Remove power
6 Reinstall the 1768 modules one at a time removing and reapplying power and checking the controller PWR indicator each time
7 If the controller PWR indicator turns red the most-recently installed module is causing the red indicator
To troubleshoot 1768 modules see their respective installation instructions
Controller PWR Indicator Status
Recommended Action
Off Make sure all of the modules in the system are installed properly and are fully engaged with one another If the indicator remains off follow the corrective action below
Green The controller is providing power to 1768 modules in the systemCheck the controller IO PWR status indicator to make sure the entire system is operating properly
Red Either the controller or 1768 modules in the system need to be replaced Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 31
Examine the IO PWR Indicator
This task assumes that the power supply and controller PWR indicators are green and that you have 1769 IO modules in your system
1 If there is a 1769 power supply installed in the local bank remove it and reapply power
If the IO PWR indicator remains red go to the next step
2 Remove power and wait for all status indicators to turn off
3 Disconnect the 1769 IO modules from the system
4 Reapply power
5 Check the controller IO PWR indicator
a If the indicator is red replace the controller
b If the indicator is green one of the 1769 IO modules is causing the red indicator
To troubleshoot 1769 IO modules see their respective installation instructions
Controller IO PWR Indicator Status(1)
(1) When the controller powers up the IO PWR status indicator is momentarily red and then changes to green if there are no issues If the indicator remains red use the table above to troubleshoot the issue
Recommended Action
Off Replace the controller
Green The controller is operating properly No action required
Flashing red and green Make sure the 1769 IO modules or end cap are properly attached and cycle power
Red A 1769 power supply may be installed in the local bank or there may be an issue with the controller or 1769 IO in the system Follow the corrective action below
Publication 1768-IN004D-EN-P - December 2009
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
32 CompactLogix Controllers
Specifications1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
1768 backplane module support
2 4
Backplane current 13 A 24V 14 A 24V 20 A 24V 21 A 24V
1769 backplane current output
20 A 52V 20 A 52V
1768 backplane current output
28 A 52V 56 A 52V
Total 1768 and 1769 backplane current output
48 A 52V 76 A 52V
Power dissipation 63 W(2) 75 W(2) 83 W(2) 95 W(2)
Power consumption 313 W 336 W 480 W 504 W
Number of 1769-series IO modules max
16 30
Number of IO banks max 2 3
Number of 1768 modules available max
2(3) 4 (3)
Isolation voltage 30V (continuous)Functional Insulation TypeType Tested 500V AC for 60 s RS-232 to system
Wiring category(1) 2 - on communication ports
North American temperature code
T4
IEC temperature code Not Applicable
T4 Not Applicable
T4
Mounting screw torque 116 Nbullm (10 lbbullin) using M4 or 8 screws
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 33
1768-L43 and 1768-L43S Power Dissipation
Dimensions (HxWxD) approx
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
1316 x 674 x 1218 mm (518 x 265 x 480 in)
1316 x 90 x 1218 mm (518 x 355 x 480 in)
Weight approx 034 kg(119 oz)
045 kg (159 oz)
034 kg (119 oz)
045 kg (159 oz)
Enclosure type rating None (open style)
(1) Use this Conductor Category information for planning conductor routing Refer to Industrial Automation Wiring and Grounding Guidelines publication 1770-41
(2) See related Power Dissipation chart that follows(3) Important You can have any combination of motion and network modules installed in a system
There is a maximum limit of two network modules that can be installed in a system Network modules include 1768-ENBT 1768-CNB 1768-CNBR and 1768-EWEB
1768-L43 1768-L43S 1768-L45 1768-L45S Controllers
Attribute 1768-L43 1768-L43S 1768-L45 1768-L45S
0 5 10 15 20 25
6
8
30
4
2
63 W
28 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
75 W
40 W
1768-L43S1768-L43
Publication 1768-IN004D-EN-P - December 2009
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA ltFEFF005500740069006c006900730065007a00200063006500730020006f007000740069006f006e00730020006100660069006e00200064006500200063007200e900650072002000640065007300200064006f00630075006d0065006e00740073002000410064006f00620065002000500044004600200070006f007500720020006400650073002000e90070007200650075007600650073002000650074002000640065007300200069006d007000720065007300730069006f006e00730020006400650020006800610075007400650020007100750061006c0069007400e90020007300750072002000640065007300200069006d007000720069006d0061006e0074006500730020006400650020006200750072006500610075002e0020004c0065007300200064006f00630075006d0065006e00740073002000500044004600200063007200e900e90073002000700065007500760065006e0074002000ea0074007200650020006f007500760065007200740073002000640061006e00730020004100630072006f006200610074002c002000610069006e00730069002000710075002700410064006f00620065002000520065006100640065007200200035002e0030002000650074002000760065007200730069006f006e007300200075006c007400e90072006900650075007200650073002egt ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
34 CompactLogix Controllers
1768-L45 and 1768-L45S Power Dissipation
Environmental Specifications
Attribute Value
Temperature operating
IEC 60068-2-1 (Test Ad Operating Cold)IEC 60068-2-2 (Test Bd Operating Dry Heat)IEC 60068-2-14 (Test Nb Operating Thermal Shock)060 degC (32140 degF)
Temperature nonoperating
IEC 60068-2-1 (Test Ab Unpackaged Nonoperating Cold)IEC 60068-2-2 (Test Bb Unpackaged Nonoperating Dry Heat)IEC 60068-2-14 (Test Na Unpackaged Nonoperating Thermal Shock)-4085 degC (-40185 degF)
Relative humidity IEC 60068-2-30 (Test Db Unpackaged Nonoperating Damp Heat)595 noncondensing
Vibration IEC 60068-2-6 (Test Fc Operating)5 g 10500 Hz
Shock operating IEC 60068-2-27 (Test Ea Unpackaged Shock) 30 g
Shock nonoperating IEC 60068-2-27 (Test Ea Unpackaged Shock) 50 g
Emissions CISPR 11 Group 1 Class A
ESD immunity IEC 61000-4-2 6 kV contact discharges 8 kV air discharges
EFTB immunity IEC 61000-4-4plusmn4 kV at 5 kHz on communication ports
0 5 10 15 20 25
6
8
30
4
35
2
40
28 W
83 W
Power Dissipated (Watts)
1768 and 1769 Bus 52V Load (Watts)
95 W
40 W
1768-L45S1768-L45
Publication 1768-IN004D-EN-P - December 2009
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
CompactLogix Controllers 35
Radiated RF immunity IEC 61000-4-310Vm with 1 kHz sine-wave 80 AM from 80hellip2000 MHz10Vm with 200 Hz 50 Pulse 100 AM 900 MHz10Vm with 200 Hz 50 Pulse 100 AM 1890 MHz3Vm with 1 kHz sine-wave 80 AM from 2000hellip2700 MHz
Surge transient immunity
IEC 61000-4-5plusmn2 kV line-earth (CM) on communication ports
Conducted RF immunity
IEC 61000-4-610V rms with 1 kHz sine-wave 80AM from 150 kHzhellip80 MHz
Certifications (when product is marked)(1)
Certification Value
c-UL-us UL Listed Industrial Control Equipment certified for US and Canada See UL File E65584UL Listed for Class I Division 2 Group ABCD Hazardous Locations certified for US and Canada See UL File E194810
CE European Union 2004108EC EMC Directive compliant withEN 61326-1 MeasControlLab Industrial RequirementsEN 61000-6-2 Industrial ImmunityEN 61000-6-4 Industrial EmissionsEN 61131-2 Programmable Controllers (Clause 8 Zone A amp B)
C-Tick Australian Radiocommunications Act compliant withASNZS CISPR 11 Industrial Emissions
Ex 1768-L43S and 1768-L45S onlyEuropean Union 949EC ATEX Directive compliant with EN 60079-15 Potentially Explosive Atmospheres Protection lsquonrsquoII 3 G Ex nA IIC T4 XEN60079-0 General Requirements
Functional
Safety(2)1768-L43S and 1768-L45S onlyCertified by TUumlV capable of SIL 1 to 3 according to IEC 61508 and PLeCat 4 according to ISO 13849-1
(1) See the Product Certifications link at wwwabcom for Declarations of Conformity certificates and other certification details
(2) When used with specified software versions
Environmental Specifications
Attribute Value
Publication 1768-IN004D-EN-P - December 2009
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
Allen-Bradley Rockwell Automation Rockwell Software CompactLogix GuardLogix RSLogix 5000
Additional ResourcesThese documents contain additional information concerning related Rockwell Automation httpwwwabcom products
You can view or download publications at httpliteraturerockwellautomationcom To order paper copies of technical documentation contact your local Rockwell Automation distributor or sales representative
Resource Description
EtherNetIP Modules in Logix5000 Control Systems User Manual publication ENET-UM001
Details how to configure program operate and troubleshoot EtherNetIP modules and provides technical specifications
1768 CompactLogix Controllers User Manual publication 1768-UM001
Details how to configure program and operate a 1768 CompactLogix system and provides technical specifications
Compact GuardLogix Controllers User Manual publication 1768-UM002
Details how to configure program and operate a 1768 Compact GuardLogix system
GuardLogix Controller Systems Safety Reference Manual publication 1756-RM093
Information on the safety requirements for GuardLogix controller systems
Industrial Automation Wiring and Grounding Guidelines publication 1770-41
Provides general guidelines for installing a Rockwell Automation industrial system
Product Certifications website httpwwwabcom
Provides declarations of conformity certificates and other certification details
Publication 1768-IN004D-EN-P - December 2009 PN-48443Supersedes Publication 1768-IN004C-EN-P - October 2008 Copyright copy 2009 Rockwell Automation Inc All rights reserved Printed in the USA
ControlFlash RSLinx Logix5000 and TechConnect are trademarks of Rockwell Automation IncTrademarks not belonging to Rockwell Automation are property of their respective companies
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN ltFEFF9ad854c18cea51fa529b7528002000410064006f0062006500200050004400460020658766f8306e4f5c6210306b4f7f75283057307e30593002537052376642306e753b8cea3092670059279650306b4fdd306430533068304c3067304d307e3059300230c730b930af30c830c330d730d730ea30f330bf3067306e53705237307e305f306f30d730eb30fc30d57528306b9069305730663044307e305930023053306e8a2d5b9a30674f5c62103055308c305f0020005000440046002030d530a130a430eb306f3001004100630072006f0062006100740020304a30883073002000410064006f00620065002000520065006100640065007200200035002e003000204ee5964d3067958b304f30533068304c3067304d307e30593002gt KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA 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 JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO ltFEFF004b00e40079007400e40020006e00e40069007400e4002000610073006500740075006b007300690061002c0020006b0075006e0020006c0075006f0074002000410064006f0062006500200050004400460020002d0064006f006b0075006d0065006e007400740065006a00610020006c0061006100640075006b006100730074006100200074007900f6007000f60079007400e400740075006c006f0073007400750073007400610020006a00610020007600650064006f007300740075007300740061002000760061007200740065006e002e00200020004c0075006f0064007500740020005000440046002d0064006f006b0075006d0065006e00740069007400200076006f0069006400610061006e0020006100760061007400610020004100630072006f0062006100740069006c006c00610020006a0061002000410064006f00620065002000520065006100640065007200200035002e0030003a006c006c00610020006a006100200075007500640065006d006d0069006c006c0061002egt SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |
This tab summarizes Rockwell Automation Global Sales and Marketing preferred printing standards It also provides guidance on whether a publication should be released as JIT (print on demand) or if it requires an RFQ for offset printingFind your publication type in the first section below Use the assigned Printing Category information to determine the standard print specifications for that document type The Printing Categories are defined below the Publication Type section Note there may be slightly different print specifications for the categories depending on the region (EMEA or Americas)For more information on Global Sales and Marketing Printing Standards see publication RA-CO004 in DocMan | |||||||||||||
Publication Type and Print Category | |||||||||||||
Publication Type | Off Set Print Category Spec (See table below) | JIT Spec (See table below) | Description | Order Min | Order Max | Life Cycle Usage Release Option | |||||||
AD | NA - Puttman | NA | Advertisement Reprint Colour | NA | NA | Presale Internal | |||||||
AP | A3 | D2 | Application Solution or Customer Success Story | 5 | 100 | Presale External | |||||||
AR | NA | NA | ArticleEditorialByline | NA | NA | Presale Internal | |||||||
(press releases should not be checked into DocMan or printed) | |||||||||||||
AT | B3 B4 | D5 | Application techniques | 5 | 100 | Presale External | |||||||
BR | A2 Primary A1 | NA | Brochures | 5 | 100 | Presale External | |||||||
CA | C2 Primary C1 | NA | Catalogue | 1 | 50 | Presale External | |||||||
CG | NA | NA | Catalogue Guide | 1 | 50 | Presale External | |||||||
CL | NA | NA | Collection | 5 | 50 | Presale External | |||||||
CO | A5 A6 A9 | D5 | Company Confidential Information | NA | NA | NA Confidential | |||||||
CP | E-only | E-only D5 | Competitive Information | 5 | 50 | NA Confidential | |||||||
DC | E-only | E-only | Discount Schedules | NA | NA | Presale Internal | |||||||
DI | A1 A3 | NA | Direct Mail | 5 | 100 | Presale Internal | |||||||
DM | NA | NA | Product Demo | 5 | 50 | Presale Internal | |||||||
DS | B3 | D5 | Dimensions Sheet | 1 | 5 | Post External | |||||||
DU | B3 | D5 | Document Update | 1 | 5 | Post External | |||||||
GR | B2 | D6 | Getting Results | 1 | 5 | Post External | |||||||
IN | B3 Primary B2 | D5 D6 | Installation instructions | 1 | 5 | Post External | |||||||
LM | NA | NA | Launch Materials | 5 | 50 | Presale Internal | |||||||
PC | B3 | D5 | Packaging Contents | ||||||||||
PL | E-only primary B3 | E-only | Price List | 5 | 50 | Presale Internal | |||||||
PM | B2 | D6 | Programming Manual | 1 | 5 | Post External | |||||||
PP | A3 | D1 | Profile (Single Product or Service) NOTE Application Solutions are to be assigned the AP pub type | 5 | 100 | Presale External | |||||||
QR | B2 primary B3 B5 | D5 D6 | Quick Reference | 1 | 5 | Post External | |||||||
QS | B2 primary B3 B5 | D5 D6 | Quick Start | 1 | 5 | Post External | |||||||
RM | B2 | D5 D6 | Reference Manual | 1 | 5 | Post External | |||||||
RN | B3 | D5 | Release Notes | 1 | 5 | Post External | |||||||
SG | B1 Primary B4 | D5 D6 | Selection Guide Colour | 5 | 50 | Presale External | |||||||
SG | B2 | D5 D6 | Selection Guide BW | 5 | 50 | Presale External | |||||||
SP | A1 A2 A3 A4 | NA | Sales Promotion NOTE Service profiles are to be assigned the PP pub type | 5 | 100 | Presale Internal | |||||||
SR | B2 B3 | D5 D6 | Specification Rating Sheet | 5 | 100 | Presale External | |||||||
TD | B2 Primary B3 B4 B5 | D5 D6 | Technical Data | 5 | 50 | Presale External | |||||||
TG | B2 B3 | D6 | Troubleshooting Guide | 1 | 5 | Post External | |||||||
UM | B2 Primary B4 | D6 | User Manual BW | 1 | 5 | Post External | |||||||
WD | B3 | D5 | Wiring Diagrams Dwgs | 1 | 5 | Post Internal | |||||||
WP | B3 Primary B5 | D5 | White Paper | 5 | 50 | Presale External | |||||||
Minimum order quantities on all JIT items are based on the publication length | |||||||||||||
Publication length | Minimum Order Quantity | ||||||||||||
77 or more pages | 1 (no shrink wrap required) | ||||||||||||
33 to 76 pages | 25 | ||||||||||||
3 to 32 pages | 50 | ||||||||||||
1 or 2 pages | 100 | ||||||||||||
Pre-sale Marketing | All paper in this category is White Brightness 90 or better Opacity 90 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
A1 | 4 color | 170 gsm 2pp | 100 gloss cover 100 gloss text | ||||||||||
A2 | 4 color | 170 gsm folded 4pp | 100 gloss cover 80 gloss text | ||||||||||
A3 | 4 color | Cover 170 gsm with Body 120 gsm gt 4pp | 80 gloss cover 80 gloss text | ||||||||||
A4 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 gloss text | ||||||||||
A5 | 2 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A6 | 1 color | 170gsm Silk ndash 120gsm Silk | 80 gloss cover 80 matt sheet text | ||||||||||
A7 | 4 color cover2 color textSelection Guide | Category being deleted | 10 Point Cover C2S50 matte sheet text | ||||||||||
A8 | 4 color cover | Category being deleted | 50 matte sheet text self cover | ||||||||||
2 color text | |||||||||||||
Selection Guide | |||||||||||||
A9 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Selection Guide | |||||||||||||
Gray shading indicates Obsolete Print Catagories | |||||||||||||
Post Sale Technical Communication | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
B1 | 4 color cover | 270gsm Gloss 100gsm bond | 10 Point Cover C2S | ||||||||||
2 color text | 50 matte sheet text | ||||||||||||
B2 | 1 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B3 | 1 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
B4 | 2 color | 160gsm Colortech amp 100gsm Bond | 90 Cover50 matte sheet text | ||||||||||
B5 | 2 color | 100gsm bond | 50 matte sheet text self cover | ||||||||||
Catalogs | |||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
C1 | 4 color cover | 270gsm Gloss 90gsm silk | 10 Point Cover C2S | ||||||||||
4 color text | 45 Coated Sheet | ||||||||||||
C2 | 4 color cover | 270gsm Gloss 80gsm silk | 10 Point Cover C2S | ||||||||||
2 color text | 32-33 Coated Sheet | ||||||||||||
JIT POD | All paper in this category is White Brightness 82 or better Opacity 88 or better | ||||||||||||
Category | Color Options | AP EMEA Paper Requirements | Canada LA US Paper Requirements | ||||||||||
D1 | 4 color | 170gsm white silk | 80 gloss cover coated 2 sides | ||||||||||
D2 | 4 color | 120gsm white silk | 80 gloss text coated 2 sides self cover | ||||||||||
D3 | 4 color | Cover 170gsm with Body 120gsm | 80 gloss cover 80 gloss text coated 2 sides | ||||||||||
D4 | 1 color | 160gsm tab | 90 index | ||||||||||
D5 | 1 color | 80gsm bond | 20 bond self cover | ||||||||||
D6 | 1 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D7 | 2 color | 160gsm tab | 90 index | ||||||||||
D8 | 2 color | 80gsm bond | 20 bond self cover | ||||||||||
D9 | 2 color | Cover 160gsm tab with Body 80gsm bond | 90 index 20 bond | ||||||||||
D10 | Combination 4 color cover with 2 color body | Cover 160gsm with Body 80gsm | 90 index 20 bond | ||||||||||
Gray shading indicates Obsolete Print Catagories |
ltlt ASCII85EncodePages false AllowTransparency false AutoPositionEPSFiles true AutoRotatePages All Binding Left CalGrayProfile (Dot Gain 20) CalRGBProfile (sRGB IEC61966-21) CalCMYKProfile (US Web Coated 050SWOP051 v2) sRGBProfile (sRGB IEC61966-21) CannotEmbedFontPolicy Error CompatibilityLevel 14 CompressObjects Tags CompressPages true ConvertImagesToIndexed true PassThroughJPEGImages true CreateJDFFile false CreateJobTicket false DefaultRenderingIntent Default DetectBlends true DetectCurves 00000 ColorConversionStrategy LeaveColorUnchanged DoThumbnails false EmbedAllFonts true EmbedOpenType false ParseICCProfilesInComments true EmbedJobOptions true DSCReportingLevel 0 EmitDSCWarnings false EndPage -1 ImageMemory 1048576 LockDistillerParams false MaxSubsetPct 1 Optimize true OPM 1 ParseDSCComments false ParseDSCCommentsForDocInfo true PreserveCopyPage true PreserveDICMYKValues true PreserveEPSInfo true PreserveFlatness true PreserveHalftoneInfo false PreserveOPIComments false PreserveOverprintSettings true StartPage 1 SubsetFonts false TransferFunctionInfo Apply UCRandBGInfo Remove UsePrologue false ColorSettingsFile () AlwaysEmbed [ true ] NeverEmbed [ true ] AntiAliasColorImages false CropColorImages true ColorImageMinResolution 300 ColorImageMinResolutionPolicy OK DownsampleColorImages true ColorImageDownsampleType Average ColorImageResolution 300 ColorImageDepth 8 ColorImageMinDownsampleDepth 1 ColorImageDownsampleThreshold 200000 EncodeColorImages true ColorImageFilter FlateEncode AutoFilterColorImages false ColorImageAutoFilterStrategy JPEG ColorACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt ColorImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000ColorACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000ColorImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasGrayImages false CropGrayImages true GrayImageMinResolution 300 GrayImageMinResolutionPolicy OK DownsampleGrayImages true GrayImageDownsampleType Average GrayImageResolution 300 GrayImageDepth 8 GrayImageMinDownsampleDepth 2 GrayImageDownsampleThreshold 200000 EncodeGrayImages true GrayImageFilter FlateEncode AutoFilterGrayImages false GrayImageAutoFilterStrategy JPEG GrayACSImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt GrayImageDict ltlt QFactor 015 HSamples [1 1 1 1] VSamples [1 1 1 1] gtgt JPEG2000GrayACSImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt JPEG2000GrayImageDict ltlt TileWidth 256 TileHeight 256 Quality 30 gtgt AntiAliasMonoImages false CropMonoImages true MonoImageMinResolution 1200 MonoImageMinResolutionPolicy OK DownsampleMonoImages true MonoImageDownsampleType Average MonoImageResolution 1200 MonoImageDepth -1 MonoImageDownsampleThreshold 150000 EncodeMonoImages true MonoImageFilter CCITTFaxEncode MonoImageDict ltlt K -1 gtgt AllowPSXObjects true CheckCompliance [ None ] PDFX1aCheck false PDFX3Check false PDFXCompliantPDFOnly false PDFXNoTrimBoxError true PDFXTrimBoxToMediaBoxOffset [ 000000 000000 000000 000000 ] PDFXSetBleedBoxToMediaBox true PDFXBleedBoxToTrimBoxOffset [ 000000 000000 000000 000000 ] PDFXOutputIntentProfile (None) PDFXOutputConditionIdentifier () PDFXOutputCondition () PDFXRegistryName () PDFXTrapped False Description ltlt CHS ltFEFF4f7f75288fd94e9b8bbe5b9a521b5efa7684002000500044004600206587686353ef901a8fc7684c976262535370673a548c002000700072006f006f00660065007200208fdb884c9ad88d2891cf62535370300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c676562535f00521b5efa768400200050004400460020658768633002gt CHT ltFEFF4f7f752890194e9b8a2d7f6e5efa7acb7684002000410064006f006200650020005000440046002065874ef653ef5728684c9762537088686a5f548c002000700072006f006f00660065007200204e0a73725f979ad854c18cea7684521753706548679c300260a853ef4ee54f7f75280020004100630072006f0062006100740020548c002000410064006f00620065002000520065006100640065007200200035002e003000204ee553ca66f49ad87248672c4f86958b555f5df25efa7acb76840020005000440046002065874ef63002gt DAN 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 DEU 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 ESP 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 FRA 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 ITA ltFEFF005500740069006c0069007a007a006100720065002000710075006500730074006500200069006d0070006f007300740061007a0069006f006e00690020007000650072002000630072006500610072006500200064006f00630075006d0065006e00740069002000410064006f006200650020005000440046002000700065007200200075006e00610020007300740061006d007000610020006400690020007100750061006c0069007400e00020007300750020007300740061006d00700061006e0074006900200065002000700072006f006f0066006500720020006400650073006b0074006f0070002e0020004900200064006f00630075006d0065006e007400690020005000440046002000630072006500610074006900200070006f00730073006f006e006f0020006500730073006500720065002000610070006500720074006900200063006f006e0020004100630072006f00620061007400200065002000410064006f00620065002000520065006100640065007200200035002e003000200065002000760065007200730069006f006e006900200073007500630063006500730073006900760065002egt JPN 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 KOR ltFEFFc7740020c124c815c7440020c0acc6a9d558c5ec0020b370c2a4d06cd0d10020d504b9b0d1300020bc0f0020ad50c815ae30c5d0c11c0020ace0d488c9c8b85c0020c778c1c4d560002000410064006f0062006500200050004400460020bb38c11cb97c0020c791c131d569b2c8b2e4002e0020c774b807ac8c0020c791c131b41c00200050004400460020bb38c11cb2940020004100630072006f0062006100740020bc0f002000410064006f00620065002000520065006100640065007200200035002e00300020c774c0c1c5d0c11c0020c5f40020c2180020c788c2b5b2c8b2e4002egt NLD (Gebruik deze instellingen om Adobe PDF-documenten te maken voor kwaliteitsafdrukken op desktopprinters en proofers De gemaakte PDF-documenten kunnen worden geopend met Acrobat en Adobe Reader 50 en hoger) NOR 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 PTB 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 SUO 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 SVE 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 ENU (Use these settings to create Adobe PDF documents for quality printing on desktop printers and proofers Created PDF documents can be opened with Acrobat and Adobe Reader 50 and later) gtgt Namespace [ (Adobe) (Common) (10) ] OtherNamespaces [ ltlt AsReaderSpreads false CropImagesToFrames true ErrorControl WarnAndContinue FlattenerIgnoreSpreadOverrides false IncludeGuidesGrids false IncludeNonPrinting false IncludeSlug false Namespace [ (Adobe) (InDesign) (40) ] OmitPlacedBitmaps false OmitPlacedEPS false OmitPlacedPDF false SimulateOverprint Legacy gtgt ltlt AddBleedMarks false AddColorBars false AddCropMarks false AddPageInfo false AddRegMarks false ConvertColors NoConversion DestinationProfileName () DestinationProfileSelector NA Downsample16BitImages true FlattenerPreset ltlt PresetSelector MediumResolution gtgt FormElements false GenerateStructure true IncludeBookmarks false IncludeHyperlinks false IncludeInteractive false IncludeLayers false IncludeProfiles true MultimediaHandling UseObjectSettings Namespace [ (Adobe) (CreativeSuite) (20) ] PDFXOutputIntentProfileSelector NA PreserveEditing true UntaggedCMYKHandling LeaveUntagged UntaggedRGBHandling LeaveUntagged UseDocumentBleed false gtgt ]gtgt setdistillerparamsltlt HWResolution [2400 2400] PageSize [612000 792000]gtgt setpagedevice
JIT Printing Specifications | RA-QR005F-EN-P - 8072009 | ||||||||||||||||||||||||||||||||
Printing Specification | YOUR DATA HERE | Instructions | NO | ||||||||||||||||||||||||||||||
(required) Category | D5 | Select Print Category ABC or D from category list on Introduction_Catagory Types tab | 11rdquo x 17rdquo | LOOSE -Loose Leaf | YES | Pre-sale Marketing | TOP | ||||||||||||||||||||||||||
(required) Finished Trim Size Width | 475rdquo x 7rdquo (slightly smaller half-size) | 85rdquo x 11rdquo | PERFECT - Perfect Bound | A1 | LEFT | ||||||||||||||||||||||||||||
(required) Publication Number | 1768-IN004D-EN-P | Sample 2030-SP001B-EN-P | 3rdquo x 5rdquo | SADDLE - Saddle Stitch | A2 | RIGHT | CORNER | ||||||||||||||||||||||||||
Use Legacy Number | YES or NO | 18rdquo x 24rdquo Poster | PLASTCOIL - Plastic Coil (Coil Bound) | A4 | BOTTOM | SIDE | |||||||||||||||||||||||||||
Legacy Number if applicable | Sample Legacy Number 0160-533 | 24rdquo x 36rdquo Poster | STAPLED1 -1 position | A3 | |||||||||||||||||||||||||||||
Publication Title | CompactLogix Controllers | Sample ElectroGuard Selling Brief | 36rdquo x 24rdquo Poster | STAPLED1B - bottom 1 position | A5 | ||||||||||||||||||||||||||||
(required) Business Group | Marketing Commercial | As entered in DocMan | 4rdquo x 6rdquo | STAPLED2 - 2 positions | A6 | ||||||||||||||||||||||||||||
(required) Cost Center | CMKMKE CM Integrated Arch - 19021 | As entered in DocMan - enter number only no description Example - 19021 | CMKMKE CM Integrated Arch - 19021CMKMKE Market Access Program - 19105 | 475rdquo x 7rdquo (slightly smaller half-size) | THERMAL - Thermal bound (Tape bound) | A7 | |||||||||||||||||||||||||||
BindingStitching | SADDLE - Saddle Stitch | Review key on right | Saddle-Stitch Items All page quantities must be divisible by 480 pgs max on 20 (text and cover)76 pgs max on 20 (text) and 24 (cover)72 pgs max on 24 (text and cover)Perfect Bound Items940 pgs max wcover (90 index unless indicated otherwise)Coil Bound Items580 pgs max of 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise)Tape Bound Items250 pgs max on 20 no cover240 pgs max wcover (90 index unless indicated otherwise)Double Wire Bound Items80 pgs max on 20 (if adding cover deduct equivalent number of pages to equal cover thickness) (90 index unless indicated otherwise) | 475rdquo x 775rdquo | THERMALO - Thermal Bound (Tape bound - offline) | A8 | |||||||||||||||||||||||||||
(required) Page Count of Publication | 36 | Total page count including cover | 55rdquo x 85rdquo (half-size) | Wire O - Double Wire Bound (offline) | A9 | ||||||||||||||||||||||||||||
Paper Stock Color | White is assumed For color options contact your vendor | 6rdquo x 4rdquo | Post Sale Technical Communication | ||||||||||||||||||||||||||||||
Number of Tabs Needed | 5 tab in stock at RR Donnelley | 7385rdquo x 9rdquo (RSI Std) | B1 | ||||||||||||||||||||||||||||||
Stitching Location | SIDE | Blank Corner or Side | 825rdquo x 10875rdquo | B2 | |||||||||||||||||||||||||||||
Drill Hole YESNO | NO | All drilled publications use the 5-hole standard 516 inch-size hole and a minimum of frac14 inch from the inner page border | 825rdquo x 11rdquo (RA product profile std) | B3 | None | ||||||||||||||||||||||||||||
Glue Location on Pad | Glue location on pads | 8375rdquo x 10875 | B4 | Half | |||||||||||||||||||||||||||||
Number of Pages per Pad | Average sheets of paper 25 50 75100 Max | 9rdquo x 12rdquo (Folder) | B5 | C | |||||||||||||||||||||||||||||
Ink Color | One color assumes BLACK 4 color assume CMYK Indicate PMS number herehellip | A4 (8 frac14rdquo x 11 frac34rdquo) (210 x 297 mm) | Catalogs | DbleParll | |||||||||||||||||||||||||||||
Used in Manufacturing | YES | A5 (583rdquo x 826rdquo) (148 x 210 mm) | C1 | Offset Z | |||||||||||||||||||||||||||||
Fold | Half | Sample | |||||||||||||||||||||||||||||||
Comments | C2 | Short | |||||||||||||||||||||||||||||||
Part Number | PN-48443 | JIT POD | V | ||||||||||||||||||||||||||||||
D1 | Z | ||||||||||||||||||||||||||||||||
D2 | Microfold | ||||||||||||||||||||||||||||||||
D3 | |||||||||||||||||||||||||||||||||
D4 | |||||||||||||||||||||||||||||||||
D5 | |||||||||||||||||||||||||||||||||
D6 | |||||||||||||||||||||||||||||||||
D7 | |||||||||||||||||||||||||||||||||
D8 | |||||||||||||||||||||||||||||||||
D9 |