TEXT

1957 1963-FORD TRUCK

PARTS ANDACCESSORIES

CATALOG

GENERAL INFORMATION

QUICK REFERENCE INDEX PAGE

PAINT

SECTIONS 10-24WHEELS, BRAKES

SECTIONS 30-36FRONT AXLE, STEERING

SECTIONS 40-48.3REAR AXLE, DRIVE SHAFTCOUPLING SHAFT

SECTIONS 60-60.11ENGINE

SECTIONS 70-76MANUAL TRANSMISSION, CLUTCH

SECTIONS 80-86COOLING, GRILLE

SECTIONS A70-A70.2AUTOMATIC TRANSMISSION

SECTIONS T70-A75TRANSMATICTRANSMISSION

SECTIONS 90-97FUEL, CARBURETOR, ACCELERATOR

SECTIONS 100-120.7GENERATOR, ALTERNATORSTARTER, DISTRIBUTOR

SECTIONS 130-145LAMPS, WIRING

SECTIONS 160-166FENDER, HOOD

SECTIONS 170-182 - AIR CONDITIONING,HEATER, SHOCK ABSORBER,WINDSHIELD WIPERS AND WASHERS

BODY SECTIONS - DOOR AND WINDOWSSEAT, SHEET METAL, EXTERIORMOULDING

COPYRIGHT 1970 - FORD MOTOR COMPANY DEARBORN, MICHIGAN1970FORM AF 7697-1

II

XXXVIII

1

179

285

693

835

923

-

1159

1203

Book 2

© .

AutoliteAUTOLITE - FORD PARTS DIVISION

GROUP 1000 THRU 7000

BOOK 1 OF 2

SECTIONS 50-57FRAME, EXHAUST SYSTEM, SUSPENSION

Book 2

Book 2

Book 2

Book 2

Book 2

Book 2

Book 2

SOFT TRIM

Copyright © 2012, Forel Publishing Company, LLC, Woodbridge, Virginia

All Rights Reserved. No part of this book may be used or reproduced in any manner whatsoever without written permission of Forel Publishing Company, LLC. For information write to Forel

Publishing Company, LLC, 3999 Peregrine Ridge Ct., Woodbridge, VA 22192

1957-63 Ford Truck Master Parts and Accessories Catalog EAN: 978-1-60371-088-6

ISBN: 1-60371-088-4

Forel Publishing Company, LLC 3999 Peregrine Ridge Ct. Woodbridge, VA 22192

Email address: sales@ForelPublishing.com Website: http://www.ForelPublishing.com

This publication contains material that is reproduced and distributed under a license from Ford Motor Company. No further reproduction or distribution of the Ford Motor Company material is

allowed without the express written permission of Ford Motor Company.

NNoottee ffrroomm tthhee PPuubblliisshheerr

This product was created from the original Ford Motor Company’s publication. Every effort has been made to use the original scanned images, however, due to the condition of the material; some pages have been modified to remove imperfections.

Disclaimer

Although every effort was made to ensure the accuracy of this book, no representations or warranties of any kind are made concerning the accuracy, completeness or suitability of the information, either expressed or implied. As a result, the information contained within this book should be used as general information only. The author and Forel Publishing Company, LLC shall have neither liability nor responsibility to any person or entity with respect to any loss or damage caused, or alleged to be caused, directly or indirectly by the information contained in this book. Further, the publisher and author are not engaged in rendering legal or other professional services. If legal, mechanical, electrical, or other expert assistance is required, the services of a competent professional should be sought.

II GIN.IAL INfORMATION

MASTER PARTS AND ACCESSORIES CATALOG FORM AF· '1697 (TEXT ONLY)

AUT OLITE- FORD PART S DIV IS ION

INDE X FO il GE NitAL IN f O . MATION SEC TION .... Rating or Warranty Plate Codes

P", • Abbreviations. • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • •• XXIX AutoUte sales Part Numbers ••• • •• • • ••••••• • • • • • •• •• • • • • IV Assemblv Piant Codes .. . .. . ......... .. . ..... . . • • XVI Bendix Westtnghouse Truck Air Brake Pa.rt.s ••••••• • •• • • • • IV Bodv Parts Group Numberinll: System • ••••• • ••• _, ••••••••• ill Body Type Codes • •• • •• • • • ••••••• • •• •• ••• XXX thru XXXVII CatalOQ; Formats •• • • • • •• • •• • • ••••••• • ••• •••••• • • • •••••• ill Date Codes . • • • • • . • • . • . • • • • • . • • • • • • . • • • • • • • • • • • • • • •• xxm Diesel Endne Parts •••••••••••••••••• •••••••••• •••••••• IV FoMoCo Baal.e Part Numberl.r\It • • • ••••• • • • • • • • •• •• • VW , IX,X Ford Baale Group Numbers and

Related CatalOf!: Section Numbers •• • • •••••• •• ••••••••• VII General Instructions ••• . •••••••••••• •••••••••• •• ••• ••••• n How to Order Parts . ... .... . ..... . . . . . . . .... . . .. . .. ..... V Model Codes . ..... . .. .... ... . . .... . ...... . . XVII thru xxm OrderlfllO Ford industr ial El\Il:lnes.

Power Units & Industrial Parts ........ . . . ......... . .. . IV Parts Identification ....... . . . .... . . . .. . ................. IV Part Name Index (Body Partsl ................ . ......... VII Part Name Index (Chasslsl . .. . . . ....... . ....... . .... .. . . VI Procedure for U811\1( Cataloe- . .. . . .. .......... . ..... . . .. . v

AuxlUary Transmission Codes ••• • •••• •• • • •• • ••• XXDI Dod.v Type Codes .......... . .... .. .. . . ... •· • •• xxvrn Bodv Type Descriptions • •••• ••• • •• • ••• ••• • ••••• xxvn Color Codes (Exterior Paintl ••••• (Refer to Paint Se<:tlonl Diagrams and explanation •• • ••••• .. • • •••• • •• • •• XI, XII District Codes ••••••••••• •• • • ••••••••• • •••••• • XXVI Enl[ine Codes. • • • • • .. • • • • • • • • • • • • • .. • • • .. • . • • • •• XV Front Axle Codes . . .. . .. .. . . . . ... .... ..... .. .... xxv Main Transmission Codes •••••••• , • • •• • ••••••••• XXIV Rear Axle Ratio Codes ..... .. . .. .......... XXV. XXVI Serial Number s .. .... . .... , ....... . .... . ....... . XVI Series Codes .. . .. . .. . . ... .. .. . .. .. . . .. . .. .. xm.XIV Year Codes ..................................... XVI

Section. GrouP and Basle Kumbers • • • • •• • • •. • • • ••• • •• . •• • n Sell Trim . ..... . ..... . ................ . ....... . ..... . .. V Standard and Utility Hardware . .......................... IV SYmbol Used ReRularly In CatalOjl; .. . .. . . . .... . . .. . .. .... . V Truck Ser ies Codes . .. ............. . ....... .... . ... . .. . m Year Application .. . . . . ............ . .... , .... .. ...... . .. m

GI N la.U IN ITa UCTIONS

This For d Truck Master Parts Catalog contains replacement parts and accessories information lor Ford Trucks including the Econoline, the Falcon Station Bus , Falcon Club Wagon and Falcon Deluxe Club Wagon for model years 1957 thr ough 1963. This "text" catalog Is to be used In conjunction with the llluslration Catalog, FOrm AF 7698.

The drive r 's side Is the left hand side of the vehicle and detCl r mines whether such parts as fenders, lamps, etc. are right or left hand.

Refer to the Index above for a listing of the various Items appearing In the Gener al Wormation Section.

nCTION, oaoup an" I.SIC NUMIUS

For greater convenience this catalog Is dlv1ded Into speeUic secUonsj such as brakes, front axle, engme, transmlsl1on, etc. For example, FRONT AXLE appears in Section 30, STEERING In Section 35, REAR AXLE In Section 40, etc. The appllcable exploded illustrations are centained In separate sections which are related to the text section numbers. Fer ellllmpie, FRONT AXLE illustrations appear In D1ustratlon Section 30, of the "illustrations" Catalog, Form AF7698.

The ballc part number groups and the section numbers under whlch each Is llsted, II shown on

PaRe VII of the General Information Sectien. In addition, e ach section or group of sections is pre~ ceded by an alphabetical Index of the parts contained within the section{s). Refer to the ~Ick RefereJlCe Index on the cover.

The basle part number gro~ps sho",," on Page v n have been expanded al sho",," In the ~harts of Pagel 'Vrn,IXandX to provide for addlHonal group~ to accommodate new Imes. In numcrl~at listings, expanded numbers will be considered to follow the same sequence as the regular bastc numberl from which they are expanded and are arranged In catalogs as follows:

21 40 2.,40

2141 2.'4,

llluSirations contain basic group numbers only, Iherefore, It Is necessary to refer to the bastc group within this "text" Catalog for comt)iete applicable part number.

'ORD TRUC/( PARTS GENERAL INFORMATION

BODY PARTS GROUP NUMBERING SYSTEM

FOLLOWING IS A DIAGRAM OF THE BODY PARTS GROUP NUMBERING SYSTEM

BODYTYPE~

91

81 • CLOSED CAB t-l 82 - PANEL DELIVERY

91· TILT CAB

ETC •

• BODY GROUP

1 r"'" '" ''"''". """ """ 21402-A

T .... ____ WIWDOW ASSY. (DOOR VENTILATIWG).R.H.

• These five digits comprise the Bony Group Numbers used throughout each body parts section.

A complete group index of body parts has been included on page 1897.

TRUCK SERIES CODES

Truck models are identified throughout this catalog by truck series.

A listing of truck series and their related warranty or rating plate codes appears on pages XI thru XXVIII of the General Information Section.

Model application is often consolidated as shown below:

Example I - FlOOj350 means FIOO through F350 or FIOO, F250, F350 Example 2 - B-F-N500j600 means B500, B600, F500, F600, N500, N600

MODEL YEAR APPLICATION

Model year application is indicated by showing the first year followed by a diagonal line to imply con­tinued usage in all subsequent years until the insertion of the last year of usage, which will then be inserted after the diagonal line. If no diagonal line is shown the part is applicable only to the year shown.

Example -

57 57/60 57/

Indicates part used 1957 model year only. Indicates part used 1957 thorugh 1960 model years. Indicates part used 1957 through 1963 in this catalog and for subsequent years as indicated in the 1964/ Catalog (Form AF - 7636-A)

CATALOG fORMATS

Various formats are used throughout this catalog to coincide with the normal procedure for selecting the affected part numbers. Most areas of the catalog use a format arranged in the order shown below:

Column I 2

3 4

5

Model year Type of vehicle or equipment within a specific model year Description, Size, etc. No. required per vehicle Complete part number

Formats peculiar to a particular area of the catalog are generally self explanatory. When necessary, instructions are shown at the beginning of the affected group. For instance, the various charts and parts list method of cataloging in the Carburetor Section are explained on Page 1399 of Section 95.

III I

IV GINII .... L INFORMATION

FDRD TRUCK "ARTS

..... us IDENTIfiCATION

To assist in the identUlcaUon of various parts and major assemblles, IdenUlJcatlon numbers are shown on the parts themselves or on tags or plates attached to selected major assemblies. Refercote to identification numbers Is made throughout the catalog, and cross reference charts are provided in some areas to facilitate the selection of the service part number when the !denU· flcatlon number Is known. It 1s most important that ldenUficaUon tags and plates be retained with the part or assembly with which they are orJ.g1naUy furnlshed.

STANDARD ond UTILITY HARDW .... E

Standard and utility hardware, such as bolts, screws, fittings, etc. are Usled below the part with which they are used. To facilitate the stocking and handling of standard and utility parts by For d dealers, locator codes are preassigned by Ford Motor Company. The locator codes are shown in parentheses Immediately following or below the standard and utility part numbers.

For example, refer to Seetion 83, Page 1283, Group 8302. The part number for the bolt which attaches the brace to the R. H. &. L. H. side member is 4~741-S7-8 and the locator code is 8218. In the catalog this item is shown as 45741-57-8(B218).

AUTOLITI SALES 'A.T HUMlnS

To facilitate the stocking and handling of those service parts which are assigned both Parts and Accessories Part Numbers and Autolite Sales Part Numbers, the Autolite Sales Part Numbers are In parenthesis immediately !oUowlng or below the Parts and Accessories Part Numbers. For example, refer to Section 96, page 1520) Group 9601. The Parts and Accessor ies part Number for a carburetor air cleaner element used on a 1957 FIOO is B7A 960 1-C, and the AutoUte Sales part number Is FA-9. In the catalog this item wUl be shown as 87A 9601-C (FA-9).

OIDlRlNG fOlD INDUSTRIAL INGINES, 'OWlR UNITS one! INDUSTRIAL 'ARTS

Most of the normal replacement parts for 6 and 8 cylinder Ford industrial engines and power unUs are carried in Ford Car and Truck Dealen Inventory and the 4 cylinder gasoline as well as the 4 and 6 cylinder Diesel pariS are carried In Ford Tractor Dealers' stock. However, to obtain Ford industrial engines and power units as wet! as peculiar parts ror these units, order direc t from authorized Ford Industrial Products Dealers only .

• ENDIX WESTINGHOUSE TRUCK AtR ..... K! 'Ans

The various BendiX Westinghouse air brake parts supplied by Ford Motor Company parts depots are listed In their respective areas of the Catalog under the Ford group number and are shown in appropriate l\Iustratlons contained In the Ford Truck lliustrations Catalog, form AF-7698.

Bendix Westinghouse parts whieh are not listed in the catalog may be obtained from your Bendix Westinghouse authorized distributor .

DIESEL INGINI ond _UATED 'AnS

This catalog Includes paris Information for DIesel engines manufact\lred by the Ford of England Dagenham Plant as well as the engine accessories and engine related parts manufactured In the U. S. A. For further details , refer to 5ectloD 60. 9 o! this catalog.

Parts Intormatlon In this catalog for the Diesel engines manufactured by Cummins Engine Company, is restricted to engine accessories and engine related parts furnished by FOrd Motor Company. See Section 60.11 of this catalog. Other parts peculiar to these Diesel engines may be ordered from the Cummins distributor or dealer.

FDRD TRUCN ~ARTS

SOFT TRIM

GINIIAL INIO.MATION

Separate sectlO1ls are devoted to Soft Trim parta by model year, namely 1957 , 1958 ell: . lnstnu::Uons for seleetlng the needed soft trim part are contained. at the beginning 0{ the Soft Trim Section immedlately following the listing of body puts other IhM !JOlt tr im.

IX'LANATION OF SYMaOL * * Symbol lndh:a tes part 15 not supplied for service due to the following :

A. ~rt 11 superseded and replaced as 1nd1taled In the deurlptlon column of lui.

B. Pari tan be improvised as indicated in the descrlpUon columna! text. C. Duo to Itll function there would be little or no demand.

Always refer to the desc ription column of the lex t fo r possible substitution, or lor material speci_ fications and dimensions which may be helpful in obl.ain lng the non serviced part locaH~·.

,aOC.DUIl '01 USING CATALOO

FolloWing: Is a rl!(ommended procedure for u$1ns: this catalog:

Should an inquiry be received for a radia tor grllLe for a 11l$? P3$0 Parcel DellVj~ry model, use the foUowlng Iteps.

A. Refer to the section and page designated In the Quick Reference Index on the cover for "Cooling, GrUle·'.

B. An index. wUl be oro the dellcnated page (12$5). C, Refer to the a lphabetical nomenclature under heading "Radiator and Grme": flnd the name

GrUle (Radiator). The group number will be shown as 8200. D. Refer to Iroup 8200 and locate the year 195? In the column headed " Year" . Refer then

to column headed" Model" for P350. The part number w11l be shown as BM 8200~A.

In the event the proper nomenclature Is In dO\lbt, an alternate method of locatllll basic number would be as follows.

A, Refer to the Quick Reference Index on the cover of the WustraUoo Catalog (Form AF- 'l898). This index shows that Uluatratlonl for "Coollng - GrIDe" parts are sbowrl In Sections 80 through 85

B. The first section (80) In this group cootains an index on page 561 for all Ulustrations in Sections 80 throulth 85.

C. Refer to the Indn under head1n¥ "Radiator Grllle It Related Parts" and locate the 19$7 applicable U1ustraUon.

D. Refer to 111u8traUon and ldenl1!y the proper part whlch wUl Ilhow the gro~ number as 8200.

E. Refer to I r oup 8200 in the Text Catalog, Form AF-?698, and locate the year 195? In the column headed '·Year". Refer then to column headt'd "Model" for P350. Tile pari number will be shown as B~ 8200-A.

HOW TO 0.011 p .... n

When ordering par tl, a lways give the complete part number.

In the event the part number is not known, the following 1nformatlon should be Inc luded.

A. Complete description of part. B. Model year and body type. C. Dl.mens1on, number of teeth, 11:te, etc; 11 possible rough sketch of part. D. If appUcable 10 engine, transmlss1on, axle, steering, etc; spec1ly type;

such as 302 cubiC Inch encine, FordomaUc TransllI lss loo, Power Steerln(, etc .

E. Advise how shipment is 10 be made - F reight, EXprelS, Air, Parcel Post.

v

VI GINIIAL IN'OIMATION

PART NAME INDEX

Below are various major groupe: appearing in the Chassis and Body Secttons of tb18 Catalog. A Part Name Index covering the service detaUs and related parts for each major gTOlip of the Chassis parts area of thIs catalog Is l18ted beginning on the Index Page as listed below. Body Index Sections and pages are shown on the next page.

CHASSIS 'AITI INDEX

FtlR" TRue/( "ARTS

PART NAME INDEX· continued

lOOT 'AilS IND1X

GENfRAL INFORMATION

(THE FOLLOWING ARE MAJOR GROUPS OF THE BODY PARTS INDEX)

FORD BASIC GROUP NUMBERS and

RELATED CATALOG SECTION NUMBERS

Following IS an index of the basic group numbers and their related catalog section numbers.

A more detailed lIsting of the basic group numbers, their related expansion numbers and

functional areas Is shown on the next three pages.

CATAI.OG C4TAlOG

VII

-, COULD(; &ASIC GItOU' Hu .. au ncnONtIO.

a..Sf(: GROUl' HUM~lft SECTION MO- .... SIC Gft_ HU"Bf~ SECTION IfO. ... SIC GROu~ MUI08U SKnDHMQ.

CHASSIS PARTS CHASSIS PARTS

CHEMICALS & PAINT P>I'" 6000 - 6999 601Iwu6(l.S 9000 - 9099 90 13000 - 13399 >30 1000 - 1099 10 Cummins Diesel 60.11 9100 _ 9199 " 13400 - 13999 >3' 1100 _ 1399 U Dagenham 60.9 9200 - 9299 " 1400 - HI99 14 9300 - 9399 " 14000 - 14399 140

STANOARO TAANSMISSION 9400 _ 9499 94 14400 _ 14499 14. 2000 _ 2099 20, 20. 1 toENTFICATlON 70 14500 ~ 15999 "5 2100 ~ 2199 " CARBURETOA

2200. 2299 22,22.1 ST A"lAAD TRAf6I1ISSION IDENTifiCATION 95 16000 ~ 16599 >60 2300 ~ 2399 23,23. 1 PARTS LISTS 70.1 & Up 9500 - 9599 95 16600 _ 16999 166 2400 ~ 2599 24 CARBURETOR

2600 ~ 2799 26 ST ANOARD TRANSIIISSIDN PARTSUSTS 95.1& Up 17000 ~ 17399 170 2800 - 2999 29 KIT PARTS USTS 70A CARBtJRETOR !CIT SPEEOOIETER

PARTS USTS 95A GE:AR CHART 172 tIIIJ 172.2 3000 - 3199 30,30.1 & UP '7000 - 7U9 71 9600 ~ 9699 96 17400 - 17999 174 3200 - 3499 " 7200 - 7299 72 9700 _ 9999 97

3500 - 3599 35,35.1 7300 - 7499 73

3600 - 3999 35.1,36 7500 - 7599 75 10000 ~ 10299 100 18000 - 16199 ISO 7600 - 7999 76 ALTER/IATOR 18200 - 19999 182

REAR AXLE IOEHTIFICATIOO 103 IDENTifICATION 40 u... 40.3 AIfTDMATIC TRAN$III$$I(»I 10300 _ 10599 103

REAR AXLE IDENTIFICATlOO A70 ALTERNATtJI.

PARTS LIST 40A F 1M - 1957/6 1 A70.1 PNiTS USTS 103 . 1 & Up ALL BODY PARTS Body Index 4000 - 4199 41 elM - 1959/ A70. 2 10600 - 10999 106 4200 - 4299 42 00000 - 02999 000 4300 - 4599 43 TRANSMATIC TRAH$IiISSION 03000 - 09999 030 4600 - 4605 4I>u... 46.5 IDENTIFICATION T70 STARTER IDENTIFICATION 110 10000 - 19999 100 4606 - 4799 " 7000 - 7100 T70 11000 ~ 11299 110 20000 - 26999 200 4800 ~ 4999 481tnJ48.3 7200 - 7499 Tn STARTER PARTS LISTS 110.1 & Up 27000 - 39999 270

1500 - 7999 T75 11300 - 11999 113 40000 - 49999 400 SOOO - S006 50 50000 - 59999 500 5007 _ 5199 50.1 8000 - 8299 SO 60000 - 69999 600 5200 _ 5299 52 8300 - 8499 93 OISTRI6IJTDR

5300 - 5499 " 8500 _ 8599 95 tDENTlFlCATICW 120 00000 _ 69999 Soft Trim 5500 - 5699 55 8600 - 8999 96 12000 - 12999 120 (AS APPUCABlEl (By~Yf.)

5700 - 5799 " DlSTRlBUTCR PARTS LISTS 120.1 & Up

VlII GENEIAL INFOIMATION

FORD MOTOR COMPANY BASIC PART NUMBERING

BASIC PART NO.

SERIES

1000-1250 1251-1349 1350- 1499 1500-1724 1725_1999 2000-2874 2875- 2999 3000- 3499 3500_3776 3777-3999 4000- 4999

5000- 5149 5150- 5199 5200- 5299

5300-5350 5351-5416 5417- 541>4 5455-5481

5482 _5499 5500- 5515 51>16- S999 6000-6899 6900-6944 6945-6999 7000-7999 8000-8499 8S00- 8599 8600-8669 8670-8999

9000-9423 9000-9269 9424-9499 9500-9699 9700-9899

9900-9999 10000,10399 10400-10499 10500-106~. 9

1061>0-10837 10838-10999 11000-11529 11530-111>68 11569-11619

11620-11644 11645 -11688 11689-11999 12000-12427 12428-12449 12450-12499 12500-12999

C HAS S IS, EN GIN E and ELE CTR IC AL BA S IC NUMBER S ERIE S

BASIC SERIES

EXPANSIO N

PARTS WH ICH QUALIFY BV F UNC TIONAL AREA

lAOOO-1A250 Wheels, hubs , and drums lA251-1A349 Open numbers lA350- 1A499 Spare wheel carrier lA500- 1A724 Tires and tubes lA725-1A999 Open numbers 2AOOO-2A874 Brakes 2A875- 2A999 Air compressor 3AOOO-3A499 Front axles andrront suspensions 3A500- 3A776 Steering gear and steering wheel 3A777-3A999 Open numbers 4AOOO _4A999 Rear axle and drlveshaft and

coupling shaft 5AooO- 5A149 Frame and brackets 5A150- 5Al99 • 5A200-SA299 Muffler, exhaust pipes, and

brackets

I>A300- I>A350 Front springs I>A351 - I>A416 Sub-frame (for cab mounting) 5A417_5A454 Open (lumbers 5A41>5- SA481 Front springs- clips, studs, and

bushings 5A482- 5A499 Stablitller and attaching parts SASOO_5A515 Front spring covers 5A516_5A999 Rear springs and attaching parts 6AOOO_6A899 Engine and mounts SA 9OO-SA 944 • 6A 941>-6A 999 Eng, instal".atlon & dress - up kits 7AOoo-7A99!l Transmission and clutch 8AooO-8A499 Radiator and gril le parts 8ASOO-8A59" Water pumps 8A600-8A6611 Fan and brackets 8A670- 8A 999 Open nUmi)., rs

9AOOO-9A423 Fuel ta.nk, gauges, pumps & l ines 9AOOO-9A 269 Fuel tank, gauges, pumps & lines 9A 4 24 _ 9A4 99 Manifold, clamps, thermOslats etc, 9ASOIJ- 9A6!l9 Carburetors & air cleaners 9A 700- 9A899 Thermostattc choke, acc. spark &

th:ottle tontrol rods 9A900_9A999 •

10AOOO-IOA39!1 Generators & alternators 10A400-10A4 9fl Open Ilolmbers 10A500-10A64fl Generator regula tor l0A650-10A837 Batteries & ammeters 10A838-10A99~ Instrument cluster & controls llAOOO - llA52~ Starting motor & starter swltcll 11A 530-11A568 Open numbers llAI>69-11A619 IgnItion switch

11A620-11A644 Open numbers llA645 - IIA688 LlglltLllg switch 11A 689-l1A99!' Open :'lumbers 12AOOO-12A427 Coli, distributor & spark plug" 12A428-12A44!' Open numbers 12A450-12A4(1) E'lglne governor 12A500-12A99? Open numbers

BASIC PART NO .

SER IES

13000-13299 13000-13399 13400-13699 13700-13799

13800-13949 13950-13999 14000- 14689

14690-14724 1472S-14999

150OO-1S074 11>075-15114 15115 ·15199

15200-1 5399 11>400 · 15489 11>490-15579 15580-151>99 15600-15649 15650- 15655 \1>656-15699 15700-15724 15725-15759

11>760- 15799 15800-11>649

IS85O-15874 11>875-15899

15900 - 15999 16000-16299 \6300-t6449 16450-16549 161>50-16579 16560-16599 16800-16999 17000-17149 \7150-11249 17250-17384 1738S-11399 17400-17674 11671>-17748 17749-17999

18000-18199 18200-18241 18242-18699 18700-18799 18800-19499 191>00-191>49 19550-19999

BASIC SER IES

EXPANSION

PARTS WHICH QUAUFV BV FUNCTIONAL AREA

13Aooo-13A29!1 Headlamps & parking lamps 13A300-13A39fl Turn signal 13A400-13A69\l License, tail, and stop lamps 13A700- 13A791l Courtesty, dome and instrument

lamps and switches 13A800-13A 949 Horn 13A9S0- 13A99fl Open numbers 14A000-14A68IJ Wlrlm! and circuit breakers.

termwls and connectors. window regulator, fuse panel

14A690-1 4A724 Seat regula tor (electrical) 14A725-14A99t' Junction boxes and electriC

conduit 15AOOO-15A074 Clocks & cigar lighter 15A075-15A 1I4 Lamp assy. -cluster 15AI15 - 15A19f' •

15A200-15A39~ Road & spotlamps 15A400-15A461' Lamp assy. -marker 1SA490-15A57!1 Lamp assy. back up & utlllty II>A560-II>A599 Lamp assy. _Police flasher 15A600- I I>A649 • 15A650-15A655 Map lamp 15A656-15A699 Top control 15A700-1SA724 Engine compartment lamp ISA725-15A759 Commercta! pump motors

Note: Not used Passenger Car. Truck & Industrial Engines

lSA760-11>A799 C\ten numbers II>A800 - 15A649 Lamp assy. _transmission

control sel ector indicator 15A850-1SA874 Parking brake signal 15A675.15A899 Open numbers

15A900-15A999 • 16AOOO-16A2[H' ~ront ie'lder, aprons & Shields 16A300-16A449 Rear fenders 16A450-16A1>49 Running bOllrdS and brackets 16A550-16A579 Splash shieldS t6A580 -1 6A599 ~en numbers 16A600- 16A999 Hoo:!, brll.ckelS and controls 17AOOO-17A14lJ Tools 17A150-11A249 Open numhers 17A21>0-17A384 Speedometer and tachometer 11 A385-11 A399 Open numbers 17A400- 17A674 Wipers a:'ld \Wsllers 17A675 _17A748 Rear view mirrors 17A749-17A999 Front nnd r('ar humpers and

stone deflectors

18AOoo-18A199 Shock absorbers 18A200 -1 8A24 1 • 18A242 -18A699 Heaters 18A700-18A799 Air brakes 18A800- 19A499 RadiO 19A500-19A1>49 MisceUaneo~s Accessories 19A51>0-19A999 Air conditioners

• This series has become tnacUve and parts qua llfylng wi I be 1 entiften wltll part numh€rs from a more appropriate serIes

CASIC PA~T tiO .

SERIES

00000-00099 00100-00399 01400-01499 01500.0 1599 OHI00. 01799 0 1800-01999 02000· 02tl99 02700-02899 02900-02999 03000· 03999 04000-04249 04250-04399 04400· 04599 04600'· 04799

04800-0~899

04900-05999 08000-06199 06200-09999 10000-10999 11000· 11099 11100-11499 11 500- 11799 11800- 11999 12000· 12099 12100- 12299 12300- 12599 12600·12699 12700-12999 13000- :3199 13200-13299

13300·13499 13500-13599 13600·13799 1401)0· 14199 14200- 14299 14300_ 19999 20000-20799 20800_21099 21100·21299 21300-213Q9 21400-22399 22400· 22499 22500·22599 22600-22699

22700-22799 22800_22899 22900·22999 23000-23399 23100-234 99 23500-23499 23600-23699 23700·24\99 2~2oo-24299 24300_ 24 599 24600-24999 25000-25099 25100- 25399 25400-25899

FDRD TRUCK ~ARTS GIN IIAL INfORMATION

IX

BODY BAStC N UMB ERS and CORAESPONOING F UN CTIO NS

8ASIC PARTS WHICH QUot.Ll FY 8"SIC 8A51C 'ARTS WHICH QUALIFY SERIES BY FUNCTIONAL ARE" PART HO . SERIES BY FUNCTIONAL AREA

EXPANSION SERIES EX PA NSION

OOOAOO·OOOA99 Body assy. lr. trim sets 25900-25999 259AOO-259A99 Opo, OOIAOO-003A99 Front end assembly 26000-26199 260Aoo_26IA99 Rear door relntorc:cmcnl 014.1,00·0 14.1,99 VenlliaHng dU(ts " val ves 26200_26399 262.1,00-263.1,99 Rear door glass frame 0ISAOO·OI5A99 Brake pedal BPI'POrt 26400-266DII 264AOO-266AII{I Rear door lock" handles 016A00-0 17A99 Dash assembly 26700· 26799 267AOO_267A99 Opo, 0181\00-0 19A99 Ventllatlng duels" valves 26800_26899 268.1,00- 268.1,99 Rear door Mnge 020A00·02tlA911 Cowl" front body pUlar 26900·26999 269AOO_261M99 Open 027 AOO-028A99 0", 27000·27299 270AOO-272A9f1 Rear door chetk &regulator 029'\oO-029A99 Deely front tie bow braces, etc. 27300_27399 273Aoo- 273A9 Rl'ar door regulator vacuum Wt 030AOO_039A99 Windshield assembly 27400-27699 274AOO.276A99 Rear door !rlm 040A00-042A49 Visor assembly 27700-28099 277AO~ ·280A9{l QlI3rter & qll3rter panel assy. 042A50-M3A99 Fron! belt raJ! Insl. panel assy. 28100-28399 281AOO-283A99 Quat'ler lock plliar 044Aoo·045A99 Panel assy. -lnstr. panel details 28400· 28499 284AGO_2B4A99 Open 046AOO-0~ 7A99 Cigar lighter assy.& InSlr. 28500·28699 285A00-286A9f\ QlI3rter header & frame

duster 28700-28199 2B7AOO·287A99 Quarter belt rail

048Aoo-M8A99 Ash receptacle assy. 28800-28999 288Aoo-289A99 0", 049Aoo-059A99 0",,, 29000_29199 290Aoo-29 1A99 Quarter window garnish mldg. 060AOO-06IA99 Glove cornpt. assy. 29200-29599 292AOO_2!l5A99 Quarter relnt. braces & brkts. 062AOO-099A99 Opo, 29600- 29999 296A00-299A9f1 Quarter Window, glass & Channel I OOA 00- 1 09A 911 F loor sIde" crossmemhers 30000-30199 300A00-301A9!' Quarter glass run" regulator IIOAOO- 110A99 Unde rbodyassy. 30200_30299 302A00_302A99 Quarte r vent. window I11Aoo·114A9!1 Floor pan assy. silencers" pads 30300- 30699 303.A(y~-306A 9r Qtr. window regulator" frame 11 5Aoo·I17A99 Floor board assy. 30700-30199 301AOO-307A99 Quarlerarm reSI ash receptacle l 1BAOO_ 11 9A99 0",,, 30BOO.30999 30SAOO-309A99 Opo, 120AOO·120A99 Floor board riser 3 1000·3 14.99 3 10Aoo.31 4A99 Quarter trim as.oty . .r. assist loop 12JAOO·122A99 F loor trans. cover dust sealer 31500-31599 315Aoo-315A9P 0", 123Aoo_ 125A99 Opo, 31600-31899 316AOO- 318A9P Qtr.arm relit aSllY. 126A00·126A99 Floor sk id strip 31900·31999 319AOO·3t9A9!l Quarter panel spare wheel cOm~. 127AOO_129A99 Opo' 32ooo- !211111 320AOO- 321A 9!l Op," 130AOO_13 1A99 Floor mOl! " carpet 32200-32399 322.A00-323A9f1 Side lllatll·trim 6ttckll-antl_ 132AOO·132A99 Floor scuff plate squeaks

133Aoo·134A99 0", 32400-32499 324Aoo-324A9!" Quarter folding compt. *pKg. 135Aoo_ 135A99 Floor tool box 32500-39!l99 325AOO-399A9r Op'" 136AOO- 137A99 ""', 40000-40199 400AOO-401A9!l Dolek door" luggage compartment 140A00-141A9!l Member assy. body IIlde frt • .r. rr. 40200·40399 402AOO·403A9!l Tall R3-te " back panel any. 1~2AOO-142A99 Sl11 allsy. -floor pan cross fr ont 40401,. 40499 404.AOO-404A9f1 LUI gate 143AOO-J99A99 0",,, 40500-40599 405AOO·405A9!l Open 200AM-207A9P Body s ide and front door 40600- 40699 <06AOO- 406A9!l LuggagC! compt. door panel 20BAOO-210A99 Front door garnish mldg. 40700-40799 4 07AOO-407A9~ Tall g:lte panel assy. 211AOO_212A99 Front door reinforcement 40800· 401199 408AOO·~09A9P Dack door & taU gate frame assy. 213AOO_213A99 0",,, 41000-41099 4l0A00_4 10AQI' 1\.1~1t door pi!lar llIlor. 214AOI1-223AII? Front doo,' glass, lock .r. fram e 41l00-4 11 99 411AOO-411A9f1 0", 224Aoo-224A99 Front door handles ~ 1 2oo-41299 412A00-412A 9!' Deck pillar group 225,\OO·225A99 0", 41 300·41399 413AOO-4 1JA99 Luggage compt • .r. IUt gate door 226A00- 226A99 Front door handles-Inside h:>ader

41400-41599 414AOI)·415A9!l 0",,,

227Aoo_227A99 Opo, 228Aoo-228A99 Front door hinge 41600-4 1699 416A00-4 16A9t' Tall ga te framing 229AOO_229A99 Front door vent llallng wirdow 41700· 41899 417AOO-418A9f1 Back belt ra il 230A00-23lA9!1 Fr<I.tt door dovetall & r egulator 41900-4199? 419AOO·4 19A9!' 8.lck door glasll .r. fra mtng 231Aoo-234A9!l Fronl door " window regulator. 42000·42299 420A0O-422A9? Back Window glass.r. frame allIlY. 234AOO-235A99 Front door check 42300-42499 42JAoo-424A91' Back wIndowgarnLsh mooldlnt 236Aoo.236A99 0", 42500·42599 ~25AOO·425A99 Back door finlshslrip-mouldlngll 237Aoo- 241A9P Front door trim & arm r elt 42t100·42699 42t1Aoo-42M9P Tall ga le C«iS1I flnLsh IItr ip 242Aoo· 242A99 HydraaUc window operaUI\It 42700·42899 427AOO·428A99 Luggage cOmpt. hinge aSllY. -243AOO_245A99 Center pUiar assy. lamp assy. 246Aoo·249A911 Rear door aIlSY. " panels 42900·42999 429AOO·429A9f1 Back door hinge & reW. allsy. 250AOO_250A99 Rear door fram e .r. pillar any. 43000-43099 430AOO_430A99 Tall gate binge assy. 251AOO-253A9!' Rcar door header" bottom 43100-43199 43 1 AOO-~3 IA 9!, Back door .r. tall gate lock 254AOO-258A9f1 Rear door glallll " garnish midi . 43200-43399 432Aoo·~33A99 Lut':ltalte compt.iO(:k assy.

x

8 ASIC PAItT NO. SERIES

43400·43499 43500·43699 43700-43899 43900. 43999 44000. 44099 44100_44199 44200-44299 44300- 44399 44400-44599 44600_4ofti99 44 700-44799 44600-45099 45100- 45199 45200-45399 45400-45599 45600_45699

45700-45799 45800_45899 45900-45999 46000- 46099 46100-46 199 46200 _46299 46300-46399 46400-46499 46500-46999 47000-47299 47300-47999 48000-48099 48 100- 49999 50000·50299

50300- 50799 50800-5 1299 51300-51399 51400_51599

S16OO-51699 5 1700_51799 5 1800-5 1899 51900-52299 52300_52499 52500-52599 52600-52699 52700_52999 53000-53099 53 100_53199

53200-53399 53400_53499 53500_53699 53700-53799 53800_53899 53900-54 299 54300-54399 54400-54499 54500-54599 54600-54799 54800-54899 54900-54999

GI!NIIAL INFORMATION FORD TRUC/( "ARTS

BODY BA SIC NUMBERS an d CORRESPOND I NG FUN CTI O NS · cont inued

BASIC BAS IC BAS IC SERIES

PARTS WII ICH QUALIFY PART NO. SERIES

PARTS WHl e ll QUA LIFY BY FUNCTION AL AREA BY FUNCTIONAL ___ REA

EXPANSION SERIES EXPANSION

434.4.OO_434A9 9 Back door handle aSsembly 55000-55199 550AOO-55 1A9 II Top luggage carr ier 435AOO_436A9 II LlI£gage (omp, locking Ilandll 55200·55999 552AOO. 559A9 9()p,"

437A OO-438A9 II Back door &. IUl:g. compt. w/str lp 60000-60024 600AOO-8ooA2 4. Front seat complete - leu trim 439Aoo_ 439A99 Tall gate bumper" dowel 60025·60049 600A25-6ooA4 \I Rear seal ass)'. -opera seat assy. 440AOO_440A9 \I Back Wll'ldOIll r egulator any. 80050-60099 600ASO-600A9 9 Front .r. rear seat assy. 441AOO_441A9 9 Back door check assy. 60100-60124 60lAOO-601A2 4 Driver's seal adjustment 442AOO-442A9 9 Luggage cornpt.lId support 60 125-60199 601A25-601A9 9 Rear &. deck seat-back a881. 443Aoo-443A99 0,," 60200-60299 602Aoo-602A9 9 Driver's seat back assy. compo 444AOO_445A99 Tall gate support 60300-60499 603AOO-604A9 9 F ront seat cushion frame a88y. 446AOO_446A9 9 Back r einforCement brackets 60500_60799 60SAOO_607A9 9 Rear, aux . .r. opera cushion 447AOO-447A9 9 Back door reinf. framing 448Aoo-450A9 P Ljcompt. opening "taU gate r eW, 60800-61299 608Aoo-612A9 9 Front seat cushton" back lrame 451AOO_45 1A99 Luggage compt.draln trough 61300-6 1399 6 13Aoo_613A9 9 Rear seat back trame 452AOO-4531:99 Back trim &. curtain 6 1400_61499 614AOO-614A9 9 Rear seat side plllar_lront seat 454AOO-455A99 Luggage compl. t rim side board 456AOO-456A99 Luggage tool. compartment 6 1500 _61599 615AOO-615A9 9 Rear seat side panel

457AOO-4S7A99 Luggage compo partition board 61600-61699 616AOO-6 16A99 Front seat back panel 458AOO-458A99 Luggage compt. Shelf board 61700-62099 617 AOO-620A99 Front seat adjusting 459AOO-459A99 Luggage compl . l:unp assy. 62100-62499 621AOO-624A99 F ront" rear seat back reint. 460A00-460A91' Compartmrnt pkg. compartment 62500_62599 625Aoo-625A99 Dr lver .r. passenger seat suppt.-46 1AOO-46IA99 Tool compartment rear seat legs 462AOO-462A99 Deck step 62600-62799 626AOO-627A99 Front seat floor rest toe lI:uard 463AOO-463A99 Back door t r Im 62800-62899 628AOO-828A99 Front seat back robe cord 464AOO-464A99 Luggage compartment t rim front seat back ash r eceptacle 465Aoo·489A99 Package tray 62900-63 199 629Aoo-63 1A99 }o' r ont seat c~shloll cover. 470AOO-472A99 Spare wheel compartment center seat opera seat cushion 473AOO-479A99 """ 63\00-63\99 63 t Aoo-631A99 Front,cent@r,opera"T@ar 480Aoo-480A99 Rear rack assy. seat cushion springs 481AOO-499A99 0,," 63200- 6349<1 632A00-634A9P Seat c~shlonilltl , facing" end pipe 500AOO·502A 9{1 Roof "top usy. 63500-83699 635Aoo- 636A99 Cushion button &. welt blndlns:

50JAOO- 507AIII' Folding top parts 63700_63799 637Aoo-637A99 F ront seat side carpet 508A00-512A99 Hool reinforcement reta iners 63800-63899 638AOO-638A99 R@ar &. deck seat cushion cover 51lAOO_513A99 Roof ra il assembly 84000-64099 640AOO-640A99 Driver ' s seat rear cover 514AOO_515A99 Top bow assy . .r. dome tamp- 64200_64399 642AOO_643A99 Part ition wJrxlow operatilltl: mech.

brackets" attachIng pariS 64400-64599 &44Aoo_645A99 Front seat back cushion cover 5I6A00-516A99 Roof rib" slats 64600_64699 646AOO_646A99 Seal back , pad &. dlv18!on frame S17AOO_517A99 Roof d r ip" tin lsh mouldlnlt 64700_64899 €47AOO-6~8AOO Front" center seat spr lng.r. pad 5 18A00_5 18A99 Root partition 64800-64999 648AOO-649A99 Front, center & opera seat pad, 519AOO- 522A99 Roof headlining .r. support cardboard l. cover 523Aoo-524A99 Hoof blrxllng " cardboard 65000-85099 650Aoo-650A99 Front seat back facing 525Aoo-525A99 Top back curtain 65100-65199 651AOO-651A99 }o' ron! seat back trim raU 526Aoo-526A99 """ 65200-65299 652A00_652A99 F ront seat back cushion welt" 5:'.7AOO-529A99 Top deck" slide quarter mouldlTlfl

530AOO- 530A99 Top staCk-toggle 65300-65399 653AOO-653A99 }o-ron! seat back wadding 531AOO_531A99 Top larxlau-folding p!llar 65400-65499 654AOO-654A99 Front seat back miSC. trlm_

hassock auy.

532A00-533A9!1 Top back curtain" hyd, mech. 534AOO_534A99 Top curtain container 65500-65599 655AOO-655A99 F ronl seat back bellows 535AOO- 536A99 Top side curtain t ront l. rear 65600-65999 656AOO-659A99 0,," 537AOO-537A99 Top covers, pads and retainer s 66000-86099 660Aoo-660A99 Pedestal seat 538A00-538A99 Quarter curtain 66100-66599 661Aoo-665A99 """ 539AOO- 542A91' Folding top.r. bii.ck stay pad 66600-66899 666AOO-668A9P Rear" d£ck seat bii.ck cover, pad 54lAOO_543A99 Roo! pads" waddlng-sll@ncers " spring 544AOO- 544A99 Top dust hood &. container 66900-67099 669AOO-670A99 Rear seat cardboard L facing 545AOO_545A99 0,," 67100-871 99 671AOO-671A 91' Rear seat back arm rest cov@r 54600-547A99 Folding top cOmpl_" w{ strlp 67200-67299 672A00_672A99 Rear seat arm rest 548Aoo_548A99 Top hold down strap 67300·67599 673Aoo- 675A1I9 Rear seat silencer L heelboard 549AOO_549A99 Roof ventilator

IMI'OITANT. AS EACH INDIVtDUAL EXPANSION SlIllS IECOMlS EXHAUSTED of NUMIUS, ANOTHU SUIES WILL II ESTAILtSHED IY USE o f THE NE XT ALPHAlntCAL EXI'ANStON lUTU SUCH AS " I " Ihr ... " %".

FORD TRUC/( 'ARTS

1957/60 RATING PLATE

GENERAL INFORMATION

The Rating Plate is installed on the left front cab pillar or glove box door depending on model. On the Parcel Delivery, it is located on the right hand dash panel.

The following diagram specifies in the Serial Number: the Truck Series Code, Engine Type, Model Year, Plant which assembled the truck and numerical sequence of assembly.

RATING PLATE DIAGRAM MODEL YEAR CODE,-------...., ......-------ASSEMBL Y PLANT CODE

ENGINE TYPE CODE 11 ~ONSECUTIVE UNIT NO. CODE

TRUCK SERIES CODE l 1 L T85 Q 0 U 10001

Serio I Number (T8SQlJU 10001)

"T8S" -- T8S0 Series - Conventional Cab flQ" •• 8 cyl. _ 477 C.I.O. Engine with 4 venturi carburetor

"0" -- 1960 Model "U" .- Assembled at Louisville Plont

"10001" -- First truck assembled during model year

SERIAL NUMBER MADE IN &$ct REG. U.S.

T8500U-l000l IU.S.A.BY PAT. OFF.

W.B. COLOR MODEL DATE TRANS. AXlE

01175 VM T858 15L 40 84GIO MAX. G. Y. W. LBS. eERT. NET. H. P. R. P. M. D. S. O. I 45000 222 3200 ** WARRANTY VOID IF MAX. GROSS VEHICLE WEIGHT IS EXCEEDED

(SEE OPERATOR'S MANUAL FOR LOAD CAPACITY CHART)

P-2469 The breakdown of the Model Code, Production Date, Auxiliary Transmission Code, Transmission Code,

Rear A.xle Ratio Code and Front Axle Code shown on the Rating Plate is as follows:

175 VM T858 15L 4Q 84G

WHEE~~~~~ ___ T..J T J T MODEL CODE -

PRODUCTION DATE CODE

IT TL----FRONT AXLE COOE REAR AXLE RATIO CODE

TRANSMISSION CODE

AUXILIARY TRANSMISSION CODE

"175" -------•• - 17S" Wheelbase "VI.:" -___ • _____ Two Tone - Academy Blue and Corinthian White

"TeSS" ________ ._ Ti3S0 Unit with necessary equipment to rate a 4S,000 G.V.W.

"ISL" -.-------- Fifteenth Day of (L) Month of November

"4" ______ • ___ 3 Speed Heavy Duty - Ratio 2.14/86. When required the Auxiliary

Transmission Code will appear directly in front of Transmission Code.

"Q" __________ S Speed Exclusive Heavy Duty - Direct Drive

"84" ---------- 7.80 Rear Axle Ratio - 34M Capacity "G" • __ •• _____ IS,OOO lb. Front Axle. When required the FrontAxle Code will appear

directly in back of Rear Axle Code.

XI

XII GINIIAL INFORMATION FDRD TRUt/( ~IIRTS

1961/63 RATING or WARRANTY PLATE

The RaUng or Warranty Plate is installed on the le tt front cab plllar,lock face of left front door orglov! box door dependlJli: on model. On the Parcel Delivery. It Is located on the right hand dash panel or on right hand side of radiator support.

" 176" ''VM'' "T852" "8 lB" "5"

''N'' "N"

"4C" ''G''

" 11"

RATING OR WARRANTY PLATE DIAGRAM

DICiII<I!TY"'I!IXIDI!'----'ll r-----··S"'.--'~-T"'-Q( _0 IXIDI!--::L ~COHSECVTIW: .... 'T NO. cooe:

"T85" "0" "U" "100001"

T85 co U 100001

IU .... <- MU ... u (ThOU '_1)

T850 Series - COnventional Cab 8 Cyl. 401 C.I.D. enBine with 2 venturi carburetor Assembled at Loul..svWe Plant First truck buUt at each assembly plant

~.U,;, ~-, ... " _ v""QIf1UI NI. ... -- Ga-i;) lIR.'l lun V.(7.I'Ia o NI.".

1961

nm. ULE 511 II 4tGI

~ ~.

1963

~'~"m." •• lIe411 "'XL~ IIATIO cooe: TIIANSMISSION ecOE

AUIUL.1ARY TIIt"N~ISSlOf< COOl:

176" Wheelbase Two·tone • Academy Blue Uld COrinthian White T850 Unit witb necessary equipment to r ate the given G.V.W. Conventional Custom Cab 4. Speed Spicer 834.1·A , Ration 2.4.0/ .84.. When required the auxUlary transmission code will appear dire-cUy in front of tranaml.aalon code. 5 Speed extra heavy duty· dlre-ct drive ~ Spicer 5652. The letter "N" Is manually stamped dlreeUy following the main transmission code when New Process option Is installed Instead of Clark. 6.50 Rear axle ratio ~ 34M capactiy. 11 ,000 lb. front axle. When r equir ed the front axle code wUl appea.r dlrecUy behind the rear axle code. District code number will appear in O.s.O. space for all unit, Including recular production.

NOTE · Falcon Statlon Bus. Falcon Club Wagon and Falcon Deluxe Club Wagon are Identified In the Model space as £110. E120 or £130. Replacement parts for these models are Included In this catalog.

FDRD TRUC/( 'ARTS GENERAL INFORMATION XIII

WARRANTY or RATING PLATE ,----------------------------------

SERIES CODES . SEJ~L~~t NlsJ\~l~~:R "----------'-@-- --------i; : 85t~(~U"wom !: ~---------------- ------.------- .-

THE FIRST 3 DIGITS OF THE SERIAL NUMBER INDICATE THE TRUCK SERIES,

THE FOLLOWING CHART LISTS THESE CODES AND THE TRUCK MODEL WHICH THEY REPRESENT.

SERIESI YEAR DESCRIPTION 1 G.V.W. CATALOGED SERIES

DESCRIPTION I G.V,W. CATALOGED

YEAR CODE RATING AS - CODE RATING AS -

A8561lGZ r----- -- * HT850 (Diese~ Cllo ~o~ ~Mlrt. axle &. a/brakes 26000 C850 A95 61/63

-----..- HT950 (Diesel) ou/oa * C850 Ctlo_ Otl/ol:! 20000 C850

B:50 57/59 15000 B500 Ctl-'I 01l/09 \1M frt. axle &. hyd/brakes <I\)UUU \..:!S:>U 60/ti3 * B500 C!Stl ~o~ lliVl frt. axle <I\)UUU \..:!S:>U

B51 57/59 10000 B500 C90 0'1/015 I \1M frt. _ ~e & aibrakes 30000 C900 B60 57/:59 17000 B600 C91 5'1/58 24000 C900

60/63 * B600 C92 58 9M frt. axle & hyd/brakes 30000 C900

Bol 5$59 15000 B600 C\l4 515 11M frt. axle 30000 C900 63 * B600 C90 51l/59 I 9M frt. axle & a/ braKes lauuuu C\lOU

B64 57;59 19500 B600 00/ti3 * C950 B70 57/:59 21000 B700 C9ti :58i~~ 1~4UUU C\lOU

60/63 * B700 C97 58/59 9M frt. axle & hyd/brakes 30000 C950 B71 57/59 115M rr. axle 17000 B700 C98 515/:59 11M or l:>M trt. axle lauuuu -C\lOU B73 58/59 16M rr. axle 17000 B700 B74 57/59 16M rr. axle 22000 B700 D60 62/63 * CtiOO (Diesel) B75 57/59 22000 B750 D61 63 * C600 (Diesel)

60/63 * B750 D70 62/63 * C700 (Diesel) --t-----

B70 5'1/0\1 17000 B750 ElO til Pickup and Van * E100

COU 1015/ 0\1_ \I~frt. axle alUUU i \..:lUUU 62/63 Pickup * E100 loU/03 * C1000 Ell ~6~ StMdard Bus Jexc. H.D.) * EIOO

COl 158/ 59 31000 CllOO E12 ~-~~ Custom Bus * E100

* CHOO Ef3- Deluxe Club" Wagon ---- --- -* -- -- EToo-----Itiu/03

CU2 loll/Ol:! ~ouuu 1 CIUUU E14 62/63 Van * E100 C03 158/ 59 23M rr. ax!.e 26000 CHOO E15 63 Pickup 4850 E100 CU4 101l/09 11M or 10M frt. axle 31000 C1000 E16 63 Van 4850 EI00 C05 158/ 59 36000 CllOO E17 ~ Standard Bus (H.D.) 11 ton EI00

payload C07 158/:59 29M rr. axle 126000 CHOO FUU 015/:>\:1 Il:!M frt. axle 13.<J00.Q. F10UO C:55 1:57/:59 18000 C550 60/63 * FIOOO (Gas)

loUj03 * C550 FUl :>15/ :>\:1 130000 .!1~ C56 1

57/ 59 --TOOOO C550 60/63 * FUOO (Gas)

C60 157/58 18000 C600 Fu~ :>15/0\:1 I <I\)UUU r'lUUU 5~ 19500 C600 F03 :>15/0\:1 <laM rr. axle 12tiOOO FllOO

'tiO/63 * C600 (Gas) F~ ~Ol:! lIM or 10M tront axle lauuuu r'lUUU FU:> :>15/ :>l:! 13tlUUU FllUU

Col 5'1/:59 15000 C600 FU'I :>15/:>\:1 '~\:IM rr. axle 12tlUUU Fuuu til * C600 FlO 57/59 • 2 wheel drive 5000 FI00-4 x2_ ti3 * C600 (Gas) 60 * FIOO

Cti4 :57/:59 20500 CoOO 61/63 , 2 wheel drive * FIOO-4 x2 C70 :57/59 22000 C700 Fll 57/59 · 2 wheel drive 4000 F!QlJ.-4 x2

'60/~ * C700 (Gas) 61/63 4 wheel drive * FI00-4 x 4 F14 I:>l:! , 2_ WM~ drive 1:5000 F100-4 x 2

5;'11 0'1/59 11:5M rr. axle 17000 C700 F18 59 ' 4 wheel drive 5600 F100-4 x 4 C73 58/:59 16M rr. axle f7000 C700 F19 5\1 · 4 wheel drive 4000 F100-4 x 4 C74 57/59 10M rr. axle 23000 C700 F25 157/ 59 2 wheel drive 7400 F250-4 x 2 C75 5.2[59 23000 C750 ItiO * F250

60103 * C750 161/ 63 2 wheel drive * F250-4 x 2 C76 57/0l:! 17000 C750 F26 157/ 59 2 wheel drive 4900 F250-4 x2

161/ 63 4 wheel drive * F250-4 x 4 C80 157 '0\1 9M frt. axle & a/braKes 25000 C800 F28 159 4 wheel drive 7400 F250-4 x 4

IoU lO~ * C800 F29 159 4 wheel drive 4900 F250-4 x 4 C81 WI '0\1 20000 C800 F35 157/ 59 9800 F350 ,ctl2 1015 1 0\1 9M frt. axle & hyd/brake~ 2.!i000 C800 ItiU/53 * F350 C84 58/5\1 11M frt. axle ~6000 C800 F36 157/ 59 7700 F350

tteter to MOdel COde for complete informatiOn

XIV GENERAL INFORMATIOII'

FtlRD TRUC/( 'ARTS WARRANTY or RATING PLATE - continued

SERIES CODES SERIES YEAR

CODE DESCRIPTION G.V.W

RATING

F50 157/59 115000 160/ 63 *

F51 15-'U59 110000 F60 157/59 117000

160/ 63 * F61 157/59 115000

,63 '" F64 157 (ij9 119500 F70 15~ 159 121000

It>u1t>J '" Fn 10'/f5li 117000 F73 156/5li 126M rr. axle 117000 F74 151159 116M rr. axle 122000 F75 157 (59 117000

160 (63 '" F'II) II>' (5\1 122000 FISU 10' '0\1 17M frt. axle & a/brakes 125000

It>l ~t>~ '" FISI I~ 10\:1 120000

161 * F62 156/59 17M frt. axle &. hyd/brakes!25000 F64 156/59 19M or 11M frt. axle 25000 F85 58/59 7M frt. axle & a/brakes 125000

60/63 * F86 58/59 20000

61 * F87 58/59 7M frt.axle & hyd/brakes 25000 F88 58/59 11M frt. axle 25000

CATALOGED AS -

FS1>O F500 F51>O F600 ~OO F600 F600 F600 F700 F700 F700 F-VOO F700 F750 F750 F750 F800 F800 F800 F800 F800 F800 F850 F850 F850 F850 F850 F850

FIlO i57/56 19M frt. axle & a/brakes 129000 F900 F9l 157/56 124000 F900 F92 158 19M frt. axle & hyd/brakesl29000 F900 Fli4 1:l1S 111M frt. axle 29000 F900 F95 58/59 9M frt.axle & a/brakes 29000 F950

60/63 * F950 (Gas) F96 Oll/:>\I 24000F95(f F97 Oll/0'" \1M trt. axle IS< hyd/ brakes ~\!UUU Fli5(f F98 Oll/:>." lIM trt. axle~li_U_UU_-I-_F_"9_50 __ _

AS -SERIES YEAR DESCRIPTION 1 G.V.W.

'"C,.,.OD"'E--n.-..---+_______ RATING N70 163 ·----;----;*----+ .. N .... 70""0"(""G-:-as")-

CATALOGED

N75 163 * N750 N85 163 * N850

..::.N.c::9I-'---l51-,-=--63_+--________ -1-__ * N950 (Gas)

1'10 ~1~3 * P100 P35 157/58 5M rr. axle 8000 P350

160/63 '" P350 (Gas) P36 57/58 5900 P350 P37 158/09 ,'i.21Vf rr.:UUe 8000 P350 P40 57/59 10000 P400

100/63 * P400 (Gas) P41 157/59 7700 P400 P5057/59 15000 P500

60/63 '" P500 (Gas) -=-P~5i=-+1!5::..cj7"-/(5=-=----!9 _________ JOOOO P500

ROO 163 * NI000 (Diesel) ROT [(33 * N1!OO (Diese12 R60 163 * N600 (Diesel R6i 163 '" N600(Diesel R70 163 * N700 (Diesel

I~R:.::W:-:15-+16~:3 _ _+_------- _ e-._* __ --+N_9_5_0--'(_lD_ie_se_l~

885 163 * NT850 (Gasl 895 163 * NT950 (Gas)

T70 57/5li 28000 T700 60/63 * T700

T71 57/59 22000 T700 T7258/59 28M rr. bOgie 32000 T700 T74 58/5928M rr. bogie . 32000 T700 T75 57/59 37000 T750

'60/63 * T750 T-76 57/59 27000 T750 T80 57/59 rA;~s4~ T800

16W63 * T800 T81 57759 Albrakes 30000 T800 T82 58/59 Hyd7brakes 43000 T800

KOO 163 _* FlOOO (Diesel) T96 58/59 9M frt. axle 32000 T950 ~K0)1';'-\7.167.-3--1'---------+ * Fll00 (Diesel) T97 58/59 48000 T950 ..::.K=--.:..-95--'1f--'-63_-t-______________ * +~'950jDiese!l T98 58/59 111M or 15M frt. axle 32000 T950

T99 \58/59 51000 T9~0 L75-~63----- ------.----- -*-- --tc'f750 --.-LBo 62/63 * .. " CT800 I~U=8~5+..16=:3--+---------+- * T850 (Diesel)

L85 162/63 * CT850 U95 \ 63 ._+--__ *_-+T::.c9:...:c5--=--0--" (D::.ci:..::.e=--se:..::.l,---

-=L=-9_5_1f--'-62/1_6:3-+--__________ .. _* .. ___ -+C::..:T:.:9--=--50~ ___ I=.,...._k-_+_-------___+-_;;____Ib;n5'""(~:--:--:-nll\ W85 163 * NT8 0 Diese'l

NM 163 * NI000 (Gas) .,:.W:.:9--=---!51--=--6:3=------+ ______ . ___ f-__ *_---t=N_T_9_5_0-'--(D_i_es_e-,-l) N01 163 * Nll00 (Gas)

.;N;;;.5_0--b.16;r.-3--1---------t-"*o---+N=15""0"'0--'---- YOO 161/63 * RiOOO (Diesel) N60 163 * N600 (Gas) Y95 61/62 * R950 (Diesell N61 163 * N600 (Gas)

* Refer to Model Code for complete information

FORD TRUC/{ 'ARTS GENERAL INFORMATION

WARRANTY or RATING PLATE - continued

CODE

ENGINE CODES

,- --- ----------------- --------- --------------- ---

j !--------~~-~-~~;~~~:-;:J.-~~-;~:~-~-R-------------

!: .~ ~~~~~~~r~~~@5i!.J-~-1-Q-~R~-~~~~~~-~~---­! I

THE FOURTH DIGIT OF THE SERIAL NUMBER INDICATES BASIC ENGINE IDENTIFICATION.

THE FOLLOWING CHART LISTS THESE CODES AS WELL AS GAS OR DIESEL, NUMBER OF CYLINDERS, CUBIC INCH DISPLACEMENT, NUMBER OF CARBURETOR VENTURI AND NET HORSE POWER @ R.P.M. FOR FURTHER ENGINE IDENTIFICATION REFER TO SECTION 60 IN THIS CATALOG.

HI NET @ 'G C .I.D1 CARB. YEAR O~ CYL c.r .D. CARB. T Y P E H.P. R.P.M. CODE YEAR or CYL

D T Y P E

NET

H.P.

A 151 G 5 1223 IV Economy 93 3200 _9_ _~y6~ -~ ~ ~ ----~!ll~!J1s NH -250 1234

223 IV 93 3400

B

C

D

E

F

G

H

I

J

K

L

N

62/63 G 6 Economy p 58/59 G 8 1401 4V

IV .13~ 13600 - 60 G 8 401 4V

161 G 5 252 62/63 G 6 262 IV Heavy duty 132 3600 61/63 G 8 401 4V

i~~511 G 8 ~~~

2V Medium~ 158 14000 Q ~~j~; G 8 477 4V

G 8 2V Medium duty 146 3800 G 8 477 4V

61/63 G 8 292 2V Medium duty 135 3800 R 158/59 G 8 534 4V

158/ 59 G 8 292 4V Heavy duty IltiO 36ITO 60 G 8 534 4V

60 G 8 292 4V Heavy duty 155 3800 61/63 G 8 534 4V

6i163 G 8 292 4V Heavy duty 153 3800 -S- 161 G {) 144 TV

,62/63 D 6 330 Dagenham 104 12500 62/63 G 6 144 IV

'~6011 G Il I~~~ 4V 1187 13600 T 161/63 G_ ~- 27~ --~!~ G 8 4V 180 3600

61 G 8 332 4V 173 3600 U 157158 G If ~ 4V

62/63 G 8 332 2V 167 3800 V til/53 D 6 1672

ltiO G 8 1401 2V 182 13400 61/63 G 8 401 2V 180 3400 W 61 D 6 672

62/63 G 8 332 4V

1~~/63 G 8 477 2V ,202 3200 G 8 477 2V 204 3200 X 1 ti1/63 D 6 743

62/63 G Il 302 4V 1163 36W Y 1 611ti3 D 6 743 --

O'I/oU G ti 223 IV 1126 '4000 Z 161/63 D 6 "743 61/63 G 6 223 IV 114 3600

-~- ~s._ f--~ ~ ~ 5'1 G 8 272 2V Medium duty 1145 141W

3 Iti3 D 8 784 lo'i/oll G 8 1272 2V Medium duty 1153 14100

4 163 IT 4 1220

1~659 G 8 1302 4V 1172 13600 G 8 302 4V 170 3600

61 G 8 302 4V 163 3600 62/63 G 8 302 4V 159 3800

YEAR CODES (FROM 1957 to 1960)

THE FIFTH DIGIT OF THE SERIAL NUMBER INDICATES THE MODEL YEAR OF THE VEHICLE.

BEGINNING IN 1961 THE MODEL YEAR MUST BE IDENTIFIED THROUGH THE SEQUENCE OF ASSEMBLY NUMBER, FOR EXAMPLE 100001. THE CHART BELOW LISTS THESE CODES AND THE CORRESPONDING MODEL YEAR.

CODE I YEAn CODE YEAR CODE YEAR

7 I 1957

, Gas or Diesel

8 1958 9 1959

pliO 192 198

-

,~~~

1246 238 235

174 79

85 -e-------

HeavY duty 149

~ummins NH-180 J,till

Ptmmins NH-195 1113 173

Cummins NH-220 1208

'Cllmmlns NHE -180 1169

cumminsNHE-195 118.4

cummins V6 __ 200 l!85

Ptmmins V8-2ti5 1205

pagenham 100

CODE YEAR

10 1960

xv

@

R.P.M.

2100

13500 3400 3400

3400 3200

3200 3000 3000

,3000 4000

13600

~OO

12100

2100 3600

2100

~bO

1950

12tiOO

12tiOO

12500

XVI GINI!IAL

INFORMATION FORD TtlUCI( 'ARTS

WAR.ANTY or IATING 'LATI • continu."

SERIAL NUMBERS ('IOM lttl th, ,,, 1963 )

A production SERIAL NUMBER BLOCK SYSTEM Is used to Identify 1961/63 model years. The monthly assignment of serial numbers is indicated by model year in the following blocks.

/IIonth 1. Yr . I """ ""'"" 1961 MODIl

"OO, OOlth, ... 205,000)

~~tober , 960 NovH:lber, 1%0 Oecerr.be r, 1950 J~llua ry, 1961 february, 1961 March, 1961 Apr11 ,1 961 ~y, 1961 June. 1961 July, 1961 August, 1961

100,001 thru 109 .999 110,000 thru 119,999 120 ,000 thru 129,999 130,000 thru 139,999 140,000 thru 149 ,999 150,000 thru 159,999 160,000 thNl 169,999 170,000 thru 179,999 180,000 thru 189,999 190,000 thru 199,999 200,000 thru 205,000

""" "'""" Month & Yr. 1962 MODIL

1205,001 th r u U5, 000)

AU9ust, 96 Z05 . llll] tilT\! Zll9.999 September, 1961 210:000 thru 219:999 October, 1%1 220,000 thru 229,999 November, 1%1 230,000 thru 239,999 December, 1961 240,000 thru 249,999 January, 1962 250,000 th r u 259,999 February , 1962 260,000 thru 269,999 Mal"Ch, 1962 270,000 thru 279,999 April, 1962 280,000 thru 289,999 ~ay. 1962 290,000 thru 299,999 June , 1962 300,000 thru 309,999 July, 1962 310.000 thru 325,000 August, 1962 320,000 thru 325,000

Month & Yr. I 196:5 MODIL

1325, 001 thru 445,000)

~~ust, September, 1962 October, 1962 November, 1962 Oecember, 1962 Janu~ry, 1963 February. 1963 I'IIIrch, 1963 April,1963 May, 1963 June, 1963 July. 1963 August, 1963

, t ru ,g 330,000 th r u 339,999 340,000 thru 349,999 3SO , OOO thru 359,999 360,000 thru 369.999 370,000 t hru 379,999 380,000 thru 389 , 999 390,000 tllT-U 399,999 400,000 thru 409,999 410,000 thro 419,999 420.000 thru 429 ,999 430,000 thru 439,999 440 ,000 thru 445,000

Due to va r ying pro~uction volumes, the e~act se r hl nu~ber with which a change beCOOleS effect1ve cannot always be deteT'l1ined. \/hen se lectlri<; part numbers referenced to serial numbers. the catalog specifications should be used as an aid tn selecting the pr oper part number.

ASSEMBLY PLANT CODES

THE SIXTH D!GIT (1957/60) OR THE FIFTH DIGIi (1961/63) OF THE SERIAL NltISER INOICAHS THE PlAAT AT WHICH THE VEHICLE WAS ASSEMBLED.

THE FOllOWING CHART LISTS THESE CODES AAD THE CORRESPONDING ASSEMBLY PLANT.

PLANT CO DE ,., YEAR

19" :.'t "" 19601 P LAN T "S1 1911 1U' 1"o1 Atlanta

~ "'".'" ~ago G - O; ,m h" Dallas h> n .. [j -

DetrolrTruck -} =- NorloiX KiilSas City -- or --L PUot Plant Long Beach - L ~C- San Jo,* R R Lorain - --- n Twin City(St. PaUl} Louirw1llo 0- rr

- \-,..._ .. __ ... _ ... .. ...... _ .. _--- --- - _._-- - -- -...... - .......... .-.. -_ .. _ ... _._ .

r---·-·" ·-·---· -._ . . -.... - ---.-.- ... ... , .. ----.----- - ----.-

seRI AL Nl) MBER COLOR CODES (EXTERIOR PAINT)

, , , i :.--------- I~_?._9_Q.Y_: lQ.Q2.L._ .... _ .. __ : W.B. COLOR MODel i ~~)'''1 75 _.- -~ _.- 18S'S

THE WOE UNOER "COLOR" INOICATES THE EXTERIOR PAINT COLOR OF THE VEHICLE.

I . - - '----' _ . , REFER TO PAGES XXXVIII THROUGH xu FOR A LISTING OF THESE CODES AAD THE PART HU$ER OF THE REQUIRED PAINT.

FOR" TRUC/( 'ARTS GENERAL INFORMATION

WARRANTY or RATING PLATE - continued ,--------------------- -----------------------! r--------------- ----------------------

XVII

MODEL CODES :: St:R~$\t. N~J$~'BER \ \ ~------------:i·-8-5--6(5ti~:1-()-i:101-----------------1! L _________ ------ ----------------------------------------------

l j \~ .s. C()t()R ~t\~:L

\ i f) ijj:S:~~vM=~~

MODEL CODE

A"B"5()

AB51 AB52

THE MODEL CODE INDICATES THE TRUCK SERIES AND THE CORRESPONDING G. V. W. RATING.

THE FOLLOWING CHART LISTS THESE CODES AND THE TRUCK MODEL AND G.V.W. RATING WHICH THEY REPRESENT.

YEAR DESCRIPTION G.V.W_ CATALOGED MODEL

RATING AS - CODE

[01/62 ----

41000 HTB50 (DieSel) CUlO

161/62 I 32UUO H TBl)()\Diesel) 161/62 4500U HT85\f\DiesefT COll

4BOOO C020

YEAR I DE SCRI PT ION G.V.W. RATING

58/59 31000 ~

------ ----_. 36000

160/63 30000 158/ 59 26000 AB53 61/62 HT85O\Diesel)

A950 61/62 45000 HT9501Diesel) C030 58/59 ; 23M rr. axle 26000

oJ 41000 HT950 (Diesell C040 58/59 11M or 15M frt. axle 31000

A951 61/oJ 32000 HT950 (Diesel) C050 5B/59 36000

A952 oliO:! 4BOOO HT950 (Diesel) C070 5B/59 29M rr. axle 26000

03 45000 HT950 (Diesel) C550 57/62 ___ TBOOO

A953 03 49000 HT9""50 (Diesel) 63 I90ml

A954 103 53000 r!!-'I'95TIJnieseIT C551 160/63 10000 ---.~----- C50U 157/ 59 10000

B500 5'1/03 15000 B500 C600 57/58 1BOOO

13"501 oU/03 ------- - f()()OO-- B5TIo--~- 59/63 19500

B~ W 16000 B500 C601 60/63 15000

B~ W 18000 B500 C602 60 15M rr. axle 21000

B510 57/59 10000 B500 C603 60 16M rr. axle 21000 - C610 57/59 ~~O

B6ffiJ 57/63 17000 B600 63 i()0

B601 iOU/OJ --~----~--- 15Cfao-- 136"00 CoIl ;03 T5M rr. axI"e "22ffi)0

-BOln" 16TI/63 -----~---

lnoOO B600 C612 161/ 62 T5M rr. axle ---------.

21000

B6T() 15'1/59 15000 B600 ,63 "IDJrfft. axle, 17M rr . axle 22000

163 21000 B600 & hyd/brakes

B611 ,03 22000 B600 C613 161/ 62 16M rr.rude ---- --- --- 21TI00

B640 1:>'1/:>11 19500 BeOO ~ "'71'J'Trt: axle,l7M rr.axle nTIOO

B700 57/0:! 21000 B700 & hyd/brakes

103 20500 B700 COl4 103 T'7!VI rr. axle & a/brakes "22'00'0 B701 oU/03 17000 B700 C640 57/59 2()500

B702 oU/o:! 16M rr. roue----- 22000 B700 - C'itJ0 57/63 2~000

li3 21000 B700 C701 00/63 T7000

B703 olio:! 18.5M rr. axle 22000 B700 C702 00/02 23000

03 Hyd/brakes(14 x 2 1/2"frt.122000 B700 63 24000

B704 oU IBM rr. axle .. 122000 B700 C703 61/63 Hyd/bra:Kes 25000

103 Hyd/ brakes( 16 x 2 l/2"frt.) 22000 B700 C704 160 Hyd/brakes 25000

B705 163 A/brakes 22000 B700 161/63 tA7T:ir-akes 25000

B710 57/59 15M rr. axle 17000 B700 C706 60 lA/brakes 25000

B730 58/59 16M rr. axle 17000 B700 C710 57/59 i5M rr. axle 17000

B740 ""57/59 122000 B700 C730 57/59 TOM rr. axle 17000 C74U 07/59 23000

B'i5() 57/62 Hyd/brakes 22000 B750 C750 57/62 23000

03 Hyd/brakes( 14 x 2 1/2"frt. 122000 B750 i03 -24000

B751 OU/o~ 10M frt. axle & hyd/brakes 17000 B750 C751 60/63 T7000

103 17000 B750 C752 160/ 63 Hyd/brakes 25000

B752 01/02 16M frt. axle & a/brakes 122000 B750 C753 161/63 A/'Drilkes 25000

163 Hyd/brakes(16x2 1/2"frt. 122000 B750 C754 100 AlbiiiKes 25000

B753 101/0<: '1M frt. axle 22000 B750 C700 157/ 59 17000

163 lA/brakes 122000 B750 B754 10U/o:! lA/brakeS 22000 B750 C800 157/59 ·9M frt. axle & a/brakes 26000

B760 157/511 17000 B750 [WO'S .. II8.5'"M rr. axle & 27000 hyd/hrakes

-cuuo 58/02 9M frt. axle 31000 C1000 CB01 60/63 20000

03 32000 ClOOO CB02 60 18.5M rr. axle & 27000

(;!RIT 60/03 20000 CI000 a/brakes

C002. 60/62 33000 Cl000 01/63 122M rr. axle 27000

63 34000 C1000 C8U3 00 [21M"rr. axle 27000-

C003 163 36000 CI000 101/03 I 18.5M rr. axle & a/brakes 27000

CATALOGED AS -

CllOO CllOO CHOO C1000 CllOO C1000 CllOO CllOO C550 C550 C550 C550 C600 C600 (Gas) C600 (Gas) C600 CouO

I CoOO CoOO (Gas) CoOO (Gas) C600 CoOO (Gas)

CoOO CoOO (Gas)

CoOO(Gas) C600 C700 (Gas) C700 (Gas) C700 C'mu (Gas) C700 (Gas) C700 C7UO (Gas) C700 C7UO

IC7uU C7.tJl!. C750 C750 C750 C750 C750 C7~ C75u

C800 C800

C800 C800

C800 C800 C800

XVIII GENERAL INFORMATION FORD TRUC/( 'ARTS

WARRANTY or RATING PLATE - continued

MODEL CODES MODEL r YEAR CODEi

DESCRIPTION G.V.W. CATALOGED RATING AS -

C804~ 127000 C800 C8lO157/59 120000 C800 C820158/59 9M frt. axle & hyd/brakes 126000 C800

C840 58/59 I flM frt. axle I 26000 C800 C850158/59 I~M frCaxre & a/ brakes I 26000 C850

160/63 fI8.5M rr. axle & 127000 C850 hyd/brakes

C851160/63 C852160 [IS.EM rr. axle &

a/brakes 1~62 ~ rr.-axre 63 122M rr. axle

120000 C850 127000 C8M

127000 C850 27000 C850

C8531 m> [21M rr. axle 27000 C850 I 01/ 62 IIll.5M rr. axfe & a/brakes. 2,"'70"",0",O---+~C;.;85~0 __ _ 163 [T8.5M rr. ;rue & ~/brakes 27000 C850

(16" x 2 1/2" frt.)

C854163 f8.5M rr. axle & a/brakes 27060 (16 1/4" x 3 1/2" frt.)

C860 I 58/59 20000

C850

C850

C870158/59 9M frCaxIe & hyd/brakes 126000 C850 C880158~ llMrrt.axle 126000 C850

C!:JUU 5'7/58 30000 C900 C9lO 57/58 124000 C900

C920\ 58 9M frt.axle 129000 C900 C940158 111M frt.axle 129000 C900

MODEL YEAR DESCRIPTION G.V.W. I CATALOGED CODE RATING AS -

IJ'{uU 03 22000 C700 (Diesel)

D701 163 nooo C'lUU (Diesel) D702 63 ·24000 C700 (Diesel)

V'IU~ 103 Hyd/brakes 25UOO C7UO (Diesel) lJ7U~ 163 I A/brakes 25000 C700 (Diesel)

E100 161 3300 E100 ElO2 161 4100 E100 E100 I til I PICkUp & Van 3600 E100

162/ 03 I pickUp 3600 E100 EIU4 161 I PIckUp & Van 4350 E1uu

162/ 03 PickUp r-i350 EIOU

1ITI3 161 I Standard Bus 3600 ElOO Em 161 • Standard Bus 4350 ElOO :e-123 '61 Custom Bus 3600 EIOO E124 ,01 I Custom Bus _43~~ ElOO

~.--

E143 62/63 Van 3600 ElOO ln44 162/ 63 Van 4350 ElOO

E1511 l!i3 I Pickup (H.D.) 4850 ElOO E~ 163 Van (H.D.) \-4-850 EIOO El7C 163 Standard Bus (H.D.) 1 ton ElOO

payload

FOOO 58/59 19M frt. axle 30000 FlOOO 160 31000 FlOOO I 01/03 -·--+7.-.32"'10""00'<--hF:';~1:;'100~0;'1 (7'<G-as~)

FUOl162/63 26000 FIOOO (Gas) C950\S8/59 19M frLax1e & a/brakes 130000 C950 F002,,16.....--7c0,.,,-f--__________ 33000 FIOOO

Itm/63 Hyd/briikes 30000 C950 161 /63 34000 FI000 (GaS) F00316 ~;J -+-ic36"'0"'0~0-+F~10"'0~0+, ('G~a=s~)

C951\ 60/63 124000 C950 FOIO 58/~9 30000 FlIOO C952160/b3 IAlbriiKes 30000 C950 16U/62 36000 FlIOO

163 3-8000 FllOOJQ.asl C9531~62 e rr._~_e ______ ~?~~ C:;;9~5:;.0:;.--__ FOIT 60/62 ~6000 FiloO --~I ~~M rr. axle I 3~000 C950 ...... ~I.,..;... 6377"7.-+-__ 30000 FIlOO (Gas)

C954160/62 23M rr. axle 131000 C950 F020158~ 26000 FIOOO I 63 123M rr. axle I 32000 I C950 F03u 58/!>!:J 123M rr. axle 26000 F llUO

FO~U 58~!:J 11M or 15M frt. axle 30000 FlOOO C955161/62 ----- :r-;.::3;0;.0:;.:;..0~C;:;:95;;:;0~-- ,F'M'fj~'Il-:-;:o; !>~5~~J!:Jnt->l7i1\.l~~~---_+ ... 36li70"'00?i__f_;Fii' Inc1.;.;00;.-__ ---r<?~1-z;~6'>'-;;.3--'--~+1~ 1l;;M~~f::...:r~t"_.-~aX1==_e ___ _f_;,3~4iv00"'0_f~C~9;;50::__-- FU7uI !>8/!>!:J 12!:JM rr. axle 26000 FlIOO C9561 60 33000 C9!)0 _ ___+-~-___+fl5-"--M--.:::fr:.-=-L'-'axl="'e=--------- __ ~40-0--0_+-'-C9-5-0--- F100 57/6312 wheel drive 5000 F100-4 x 2

F'lUl/60/63 12 wheel drive-huoo-- F100-4 x 2 7'C=960ttl."..,.-,58/1.,.,,59~---~----h-24"0"'00,.---+.C=9~50,.---- !'f02160/63 12 Wheel drive-Iiooo F100-4 x 2 C970158/59 9M frLax1e&hyd/brakes 30000 C950 .---+---r----------I---

C980158/59 IflM or -15Mrrt.ax1e 30000 C950 F103 OU 14 Wheel drive 5600 FlOO-4 x 4 FI04 60 4 wheel drive -"4000 F100-4 x 4 Fl05160 14 wheel drive ':>600 F 100-4 x 4 DoW 163

---19500 I CtmO (Diesel)

D601 1 63 15000 C600 (Diesel)

DolU Iti3 121000 C600 (Diesel) Dtill 163 T5lVf rr. axJ:e 22000 C600 (Diesel)

F110157/59 12 wheel drive 4000 FI00-4 x 2 63 . 4 wheel drive -SMo F11\1\-4 x 4

--\------\--------------- ~--

"F....--r.lll1rr=--63-+14"-:-w"-heC-Ce'-l-:r d:rC7i-,-vec------ 40"'0"0"c---t-=F J~()O~·-4~x~ 4--F1TII63 14 wheel drive 5600 FIOU-4 x 4

D612 163 16M frt. axle, 17M rr. axle 2~OOO C600 (Diesel) & hyd/brakes

D613 163 17M frt. axle & 17M rr. axle22000 C600 (Diesel) D614 163 16M frt. axle, 17M rr. axle I 22000 IC600 (Diesel)

& a/brakes

Fl~ 61/62 14 wheel drive 5600 FlUO-i. x 4 FIBI Ol~ 14 wheel drive 4000 FlUO-4 x 4 F1151 olLoz 14 Wheel drive 5600 FI00-4 x 4 F140 5!:J 12 wheel drive 5000 FIOO-4 x 2 Fl80 59 14 wheel drive 5600 F 100-4 x 4 FI9(j 59 14 wheel drive 5000 F100-4 x 4

FDRD TRUC/( 'ARTS WARRANTY or RATING PLATE - continued

MODEL CODES

GENERAL INFORMATION

XIX

MODEL I YEAR DESCRIPTION G.V.W. CATALOGED MODEL YEAR DESCRIPTION G.V.W. CATALOGED CODE AS -RATING CODE RATING AS -F25() 157/63 • 2 wheel drive 7400 F250-4 x~ F730 oB . HiM rr. axle '-r-1'7000 F700 F201 loU/03 2 wheel drive

--_. 4900 F20lJ~X2 159 L<::8M rr. axle 17000 F700

l'~;>l: IOU i 2 wheel drIVe 7400 F20U~ x 2 F740 10'1/59 I HiM rr. axle : <::WUU F'IOO F253 OU 4 wheeldrive - 7400 F20u-4 x---;r-- F750 57/62 ~ F750 ~I,j IOU 14 wheel drive ----- 4900 F25U-4X4-- 163 122500 F750 ~~ . tlU 4Wfiee!arw-e ~---. ~ F250-4 x 4 F701 I tllJ;'ol .17000 F750 F20l :l'I/59 • 2 wheel drive 4900 F250-4 x 2 103 ·17000 F750

63 6600 F250-4 x-± F752 i OU/61 . Hyd/brakes 25000 F750 F201 03 4900 F250~ x 4 163 .23000 F750 F202 01/62 4 wheel Clrive 0000 F250~ x 4 F753 61 lA/brakes ~OU F750 63 7400 F250-4 x 4 163 1<::3000 F750

~3 161/62 • 4 wheel drive . 4900 F250-4 x-± F754 IoU lA/brakes 125000 F750 F<::ol,j 161/62 I 4 Wheel drive 7400 F250-4 x-± 161/ 62 122000 F'75U F28C 59 I 4 wheel drive 7400 F250-4 x-± 163 124000 F750 F~O 159 4 wheel drive 4900 F25u~x~ F755 161/62 L!.!.l!lllJ. F750

F35C 57/63 9800 F35U 163 Hyd/brakes I <::oOuO I F'150

F30 OU 77fJr5 F350 F756 15l/62 22000 F750 151 7600 F350 163 ~br~s 125~0 F750

62/63 7800 F350 F70'l 101/0<:: ,-J:iy_ctLbraKeS ~~ F750 F~ 57/59 7700 F350 F758 101/ 02 lA/brakeS I <::ouO~ F750

F750 157/ 59 17000 F750 F500 57/63 15000 F500 F5U 60/63 ' 10000 F500 F80U 5'I/oU I'IM or \!M frt. axle & 125000 F800 F'OO2 163 16000 F500 a/brakes F~~ 10J 18000 F't>~0 15l/52 I 240UU F800 F51C 157/59 10000 F5uO

163 123000 F800 l<'8Ul IOU 120000 F800

o /53 -

17000 F500 17000 F800 ~OUl 101/ 03 1"OUI 60/63 15000 Ff;OO FBU2 IoU ~ F800 FoU2 60/63 19500 F~OO 151/ 02 I 22UUU F800 l"OUol ou :nooo Fouu

163 23000 F800 F6TIl "57[5lr 15000 F600

53 21000 FoOO 1"8UJ IOU I !8.0M rr. axle III I ~'IUUU -F80lJ FoIl 10J 122000 F50U hyd/brakes Fo12 103 Hyd/brakes 123000 F600

101/ 0<:: I !8.:>M rr. axle & I <:::>UUU F800 hyd/brakes

F613 151/ 62 115M rr. axle 121000 FoOO 153 124000 F800

163 lA/brakes 123 000 FoOO F014 161/62 16M rr. axle 121000 F600 FBU4 IoU I !8.:>M rr. axle & 27000 F800 _F~ 5'7/5lr 19500 IF600 a/brakes

151/ 02 IIB.oM rr. axle & I <::oUUU F800 F7UU 107/ 62 121000 F70U a/brakes

163 120000 F700 163 24000 F800 ~! OUjOol 17000 F700

F805 loIL02 I~rr. axle I <:::>UUU F800 F702 loU/03 IHyCl/br~es 122000 F700

103 HyCl/brakes 1<::~U.lJ. F800 F703 I til/62 I Hyd/braKes 125000 F!..UU

163 122000 F700 F806 ItiO 121M rr. axle 127000 F800 ~ 116M rr. roife 122000 IF800

l"'IU'I ou I oM 1rt. altie 125000 F700 163 ~/b~es ~ F800

. 61/62 lA/braKes 25000 F.'I..UU. F807 103 11B.oM rr. axle & 27000 F800 63 Hyd/brakes 123000 F7UU hyd/brakes

Fa08 163 118.5M rr. axle & 127000 FaOO F705 161/ 52 lA/brakes 122000 F'/UU a/brakes

163 Hyd/brakes 123000 F700 'F'T06 [60 I 7M frt. axle 125000 F700 F809 103 1<::2M rr. axle I 270uu F800

103 lA/brakes 123000 F700 FalO 157/ 59 120000 FaOO

F'/u'l 10J 124000 F'/uu F2Q1I 163 I Hyd/brakes 125000 F700 1"B14 101/ 0:.1 I !8.0M rr aXfe & 127000 IF800

hyd/brakes F'IU~ ~ lA/brakes 125000 F7~0 FBI!> 101/1):.1 ~:.I~ rr. axle 127000 F800 F710 57/59 15M or 15M rr. axle 17000 F7UO FB15 101/ 02 I Hi.oM rr. axle & a/brakes 2'/lJOO FBOO

xx GENERAL INFORMATION FORD TRUCK 'ARTS

WARRANTY or RATING PLATE - continued

MODEL CODES

MODEL I YEAR I DESCRIPTION G.V.W. CATALOGED MODEL YEAR RATING AS - CODE CODE

F820 158/ 59 I 7M or 9M frt. axle & 125000 FSOO HOOO 161/ 62 hyd/brakes 163

F840 158/ 59 111M frt. axle 125000 FSOO -

H001 61/62 63

FS50 15S/59 17M frt.axle & a/br~es 125000 FS50 H002 163 160/ 63 IHyd/brakes 125000 FS50 H003 163 .. F851 160/ 63 120000 FS50 H950 161

F852 160/ 63 lA/brakes 125000 FS50 163 F853 160/ 63 IIS.5M rr. axle & 127000 F800 H951 161/62

hyd/brakes H952 161/02 H953 161/62

F854160/62 18.5M rr. axle &

DESCRIPTION G.V.W. CATALOGED RATING AS -

34000 HIOOO (Gas) 30000 HIOOO (Gas) 26000 HIOOO (Gas) 24000 HIOOO (Gas) 32000 HIOOO (Gas) 34000 Hl000 (Gas) 20000 H950 Gas 30000 H~ Gas 24000 H9OO' Gas 32000 H950 Gas ~4~00 H950 Gas

41000 HTS50 (Gas) 32000 HTS50 (Gas)

127000 FS50

1~--~a/"b.rak~es~~------~~~~~------I~JJ~850~1~6)1~//~62~------------__ ~~~~~~~~.-~~16~3 __ hI2~~M~r~r~.axl~~e~~ ____ h2~'7~OU~U~F~~S5~0 ______ ~ J85~;1~1~6)1~11~62~ ______________ +~~~~~~~~ FS55 163 I Hl.5M frt. axle & 27000 FS50 J85261/62 45000 HTS50 (Gas)

4Sg00 HT850 (Gas) 45uOO HT950 (Gas)

a/brakes JS53 61/62 TF~806M~6U--~2~1M~r=r=.rod~Ee~------~27~70~00-+'F~8ffi~0------~ Jr9~5)~'U6~;1~/'~62~--------------+T.~~hrn~nTr~,-FS60 58/59 120000 FS50 63 41000 HT950 Gas)

32000 HT950 Gas) 4S000 HT'900 Gas)

F863 61/62 18.5M rr. axle & 127000 FS50 J951 61/63

T.fl<m7FT7".,.-hh"'y ... d/-:b:::-rak=:::::es'<-=-______ ---+.....,.""'--h"""',..--___ J952 61/62 45000 HT950 Gas) 49000 HT950 Gas)

F864 ,61/62 122M rr. rode 127000 FS5063 F865 61 162 '18. oM rr. axle & a; brakjec-:s~l~ 2 7'O;:'';:'';00~~F"''S5I~0'------- 'J"""'953.-f"';'-63--+----------------+--T~ic--hT--;~ri:.:::=-<--­FS70' 58/59 7M frt.rode & hyd/brakes 125000 FS'OO

32000 FIOOO (Diesel) 26000 FIOOO (Diesel)

F880 58 159 11M frt. rode 125000 FsnO KOOO 63 F90057/5S 9M frt.axle & a/brakes 129000 F900 ~K~001l.rl-16;;;-3--~-------------t--i;-i~/;---Ih;-'.im~~~ F910 57/5S 124000 F900 K0021 63 34000 FIOOO Diesel)

36000 FIOOO Diesel) F920 58 9M frt. rode & hyd/brakesl29000 F900';;;' KOO;;;.J.316;;;-3--1-----------------h.~~/;---I~~~;:;:.::.::n-3S000 FUOO Diesery 30000

F94015S II1Mfrt.axle 129000 F900 ...,K~010+16;..;,..-3__+----------FUOO Diesel)

2S000 F950 (DieseI)

F95015S/59 19M frt.~rakes 129000 F950..::::.:: KU-=-Jlll.::.::.....63 __ +--_____________ +"-160 _.~1;2,'7~0~00~hF~~~O~;~== ~~~--+---------------~~x_~~""~~ '61/63 12S000 F95'O\GaS)..;;; K9l;.;.J.50I;;,.. 63---1 ______________ -+..;.:;:.;;;;...+.~~;=~

24000 F95O\Diesery 30000 F95OlDiesel) 30000 F950 (DieseIT :J200U :F95'0 (Diesel)

~~~~---------------k~~~un~~..;;; K95~)1~16~3-+~~~--------~~~~~~~­~~~~~-~~~-------~~~+,F~9~5~0~(G=a~s~)--~ K9~5)2rll~63--~H~y~~lb~:r~akle~s--------~~~~~~~~

~~F~<9~5~0~~--~ K9~031~63--hIA~//~brak~'eS~~------~~~~~~~TI_ ~:~~F9~~5~O'~(G~a=s~)-~ K95~41;;;_63--h1~1M.~trt~.~axlle~------~~~~~~~IT_

32000 F950 (Diesel) 34000 F950 (Diesel)

--t-----.

F950 (Gas) K955 163 19M frt. rode ~=+~=+~~~--------~~-r~~~--~ ~5~616~3~~~==~-----4~~~~~~IT-

F950 -- '35000 CT150

39()()Q CT150 27000 CT'750 37uOO CT750 41000 CT750

~--~~~~------_4~~~F9~5K-0----- L75011;6~2~ ______________ ~~.+~~ __ ___ F950 163

__ -+~~~~~~-------4~~_rF~~~·0~1~G=as~)-~ L,~'775~)1+6~2//6~3---------------+~~~~~-----~~~-h~~~~-----+~n-~~----- L75211~62~~ ____________ ~~~~~ __ ___ ~ F950 163

F950 L753 62 39000 CT750

.. '41000 CT750 39000 CTSOO 43000 CTSOO

.-h~~+,F~9~50~~__~ L,~~754~6rn-2-+ _____________ _ F950(Gas) L8UUI~6~2-+ ______________ ~~~-+~~ ____ _

63 -30000 CTSOO 27000 CTSOO

~~F~95~(0~____ LSOll;6~2-+ ______________ -h~~~~~ __ __ F950 163 c--- ___ F950

~--4---------------~iN~~~F9~l5~10"('G~a~s~)- L80262 -4TOrnJ CTSOO 63 45000 CTSOO

F957 16U 33000 F950 LS03 62 43000 CTSOO F960158/59 _____ _24000 F950 634.9_00.2_ CT~ __ __ F970158/59 !9M frt.aXle& hyd/brakes 29000 F950 ________ ~~-"~~--\-==---_-F9S0 158/59 111M fro axle 129000 F950 ___ L804162 45000 -J.--.-;.C~TS~O~O ___ _ ~....-I~---I----------------fo.MK---hI-5'j---lif-;;~;;;-;;n- L8051 62 -- 27000 CTSOO

g~~~/.';I~~33--4----------------B~iK~~~~\---ti~~}~rn,~:i «(~K~f;;::~::;T-gl- t~~~~¥~3 ~-.------- ---- 1~~- g~-~~~ .-----G400163 10000 P400 (Diesel) 163 27000 CT8~Q.. ______ ._

163 7700 P400 (Diesel) L-s-52 '02/63----- - ·rIOoo-- CTS50 gig6163 15000 P500 (Diesel)L853162/63 _=-~43000-- CTS50------Goal1e3 ____ 10~OO_ P5.o0 (Die~el) 1~/63 - -- -4.?_~CT800--

FORD TRUC/( 'ARTS GENERAL INFORMATION

WARRANTY or RATING PLATE - continued

MODEL CODES

MODELl YEAR DESCRIPTION J G.V.W. J CATALOGED MODEL YEAR DESCRIPTION G.V.W. CODE CODE RATING

r;g~ .- -''l~;;~G-CT~-----.- N950

163

._._--_ .. 28000

~ 49000 CT850 N95l loiS --f-moo

LIIOU 10Z 400(1(J CTliou Nl:Ioz 10J I Hyd/brakes 300M 163 ·mgg- CTll?O NIiOiS loiS I A/brakes

--~OOU

L95l 162 --.---- 'CT9SO-- Nllo4 oJ 11M frt. axle 32000

63 _._---- .3_Otl~U CT9aO N955 163 9M trt. axle -

32000 N950 63 -34000_

L952 62 48000--rcT9SO----· ---.. - .-----_ ..

63 .. ------

49000 CT9aU PlOO ol/o;l 40Q{j LliaiS ~.

5100a CT9~-- 63 4300 53000 CTB50 PlOl 63 5000

Llla4 i 0:& --.. ---

~roo-oo- CT950 P102 61/62 5000 _ .. -- -.---

NUUU 103 32000 NIO~ (Gas P350 .57/60 5M rr. axle 8000 NUUI 103 20000 NlUOO (Gas 101/ 03 8000 NUUZ 103 34000 NIUU.tJ (Gas 1-'3 a 1 16U/ 03 aliOU NOU3

103 36000 NlUOO (Gas P352 160/ 63 7.2M rr. axle 8000

NOlO 163 38000 NllOU (Gas P353 160/ 63 oM rr. axle 8000 NOll 63 s.Q<>QQ NllOO (Gas) P360 157/ 59 5900

Nooo -S~ P37u 15B/ 59 ~.Q.0 T5TIQO- N500 --

--tIMOO N50l 63 N500 P40U 57/03 10000

N502 ,63 16000 N500 P40l 60/63 .77U() NOUJ

.--.' ISOOo-- N500 --_ .. -'oJ P410 57/59 7700 --------

NoOU 103 -l'rooo N600 (Gas) P5UU ,57/63 15000

NoU.! 163 ... iloOOO' N600 (Gas) P501 160/ 63 10000 ._-19500 N600 (Gas) NoU2 103 P510 ,57/59 10000

NolO loiS ':rro60' NoU.tJ...(GasL -N01~ 10J

-- 22000 N0llll...(Gas~ '-I2~oou

ROOO 163 3~ No1;l 103 HYCI/orakeS- NouU (Gas) ROOI 163 ;loUUU

14" x 2 1/2" frt.) R002 163 34000

No1~ 03. A/oraKes 23000 IN~(G!S) RUUJ 103 30000 No14 oiS I Hy.CI/ orakes- 23000 Nouu (Gas) RUlU 103 38000

(16" x 2 1/2" frt.) RUll 103 30000

N'IUU ,oJ 2QQ.Q.0 N700 (Gas) -- RoOO 63 __ 19500 N70l 163 l!bOO N700 (Gas)

R601 63 I5OO0 N702 ,63 -rouo N700 (Gas) -- ~OO RolO 63 21000 N703 163 N700 (Gas)

Roll 163 22000 N704 163 I Hyd/brakes- 23000 N700 (Gas)

(14" x 2 1/2" frt.) R612 163 LHyd,IBr_akes 23000

N705 103 Hy~/braKeS- 23000 N7UU (Gas) itolJ lOiS IA/oraKes ;l3UUU

(16" x 2 1/2" frt.) N71Jtj 103 A/orakes 23UUO N'IUU Gas) KIUU 103 20000

NW'I 03 240UU NWU Gas) R701 163 17000

N7Uti 03 ' HyCi/orakes 250UU_ N'luu Gasl R702 103 21000

N7UII 03 iA/OrakeS 250U\J. N'IUU Gas;- R703 163 2~.<><>Q.

N~ 03 2250U N'lau R'IU4 lOiS HY,CI/oraKes- 23000

N'lal oiS 17000 N750 (14" x 2 1/2" frt.)

N'I:>Z oJ Hyd/brakes- 23000 N750 R'lua 03 Hyd/oraKes- 23000

(14" x 2 1/2" frt.) 16" x 2 1/2" frt.)

N753 [03 Hy,d/oraKeS- 23000 N70U R700 63 'A/brakes 23000 (16" x 2 1/2" frt.)

N754 163 24000 N7~ R7U7 103 24000

N755 163 Hyd/brakes 25000 N7~ R70B 163 25000 N'IOo 10J A/brakes 25000 N7~

R95U 103 28000

NB:>Ij lo~ Hyd/brakes 25000 N85U R951 163 24000

NBo1 10J zuu(1(J N8S0 RIIOZ 10J 110' X 2 1/2' rrt.brakes. 3UUUU

NB52 03 ,A/orakeS 25UUU N850 R903 103 1101/4' x 31/2" 30000

N853 03 IB.oM rr. axle & 27000 NHoU frt. brakes

hyd/brakes R954 63 11M frt. axle 32000 NIlO'! I);j : 22M rr. axle 27000 N80U R955 63 9M frt. axle 320Q<>. Nlloo ;I)J 18.oM rr.axle ~ a/braKeS 27000 N850 itllOo oJ 34UUU_

XXI

CATALOGED AS -

N950 (Gas) N950 (Gas) N950 (Gas) N950 (Gas) N950 (Gas) N~50 JGas) ~lIau J.G~J __

PlOO PIOO PlOO PlOO

P350 P~Gas) P3aU (Gas) P350 (Gas) P350 (Gas) P350 P350

P4QO JGas) P4(1(JJGaS) P400

P500 (Gas) P500 (Gas) P500

NlOOO (Diesel) Nwuu (Diesel) NIOOO (Diesel) NIOOO (Diesel) NllOO (Diesel) NllOO (Diesel)

N600 Diesel N600 Diesel' N600 Diesel N600 Diesel N6<JQ. Diesel, Nouu Diesel)

N700 Diesel, N700 Diesel: N700 Diesel N700 \lJies~ N700 :DieSeIJ

N7uu (DieSel)

N700 JDiesel)

N700 (Diesel) N700 (Diesel)

N950 (Diesel) N950JDiesel) N90U (Diesel) N950 (Diesel)

N950 (Diesel) N9~(Diesel)

N95U (Diesel)

XXII GENERAL INFORMATION

"ItD TItOCIl PIlItTS WARRANTY or RATING PLATE - continued

MODEL CODES MODEL YEAR DESCRIPTION G.V.W. CATALOGED MODEL YEAR DESCRIPTION G.V.W. CATALOGED CODE RATING AS - CODE RATING AS -

SS50 63 39000 NT850 (Gas T804 60 -~

43000 Taoo ~- 63 I 27uOO NTS50 Gas 61/0", _;j4M rr.axle & a/brakes 43000 T800 SS52 63 41000 NTS50 Gas O;j 149000 TSuu S853 63 Hyd/brakes 43000 NTS50 Gas SS54 63 lA/brakes 43000 NTS50 Gas T805 ~ i 34M rr. axle 3-(}000 TtlUU S855 63 45000 NT850 Gas ------ ~1!'0;j

--._ .. --- 45000 TSOO SS56 63 49000 NTS50 Gas ------

TtlUo OU 34M ri. axle ----~-- -·1'5'000- TsM S950 03 47000 NT950 Gas) 62 34M rr. axle & hyd/b~..es L43uuu TSOO

T807 62 --2S000 TSOO

--

S951 63 30000 NT950 (Gas) TtllU in/ :>9 I A/brakes 30000 TSOO S952 63 49000 NT950 (Gas) S953 63 53000 NT950 (Gas) T820 58/59 Hyd/brakes 43000 T800

Ttl3U i:>tI/:>9 Hyd/brakes 130000 Ttluu T70U 57/63 2S000 T700 'I'840 157/ 59 45000 T800 T701 60/62 22M rr. axle 22000 T7UU

03 22UUU T700 T850 158/ 59 I A/brakes 43000 TS:>O 1lO --137000 TSoO

T7U2 loU/63 29000 T700 101/ 03 39000 TS50 (Gas)

--- 30000 T703 161/ 62 32000 T700 Ttl:> 1 loU/02 TS50

163 36000 T700 103 27000 T850 (Gas)

T704 IoU -~ ¥S~~--- ~}~~- TtlO", IOU 39000 T850

161/ 62 101/ 03 TIOOO TS50lGaSY-

163 - 37UOU T700 T853 161/ 63 Hyd/brakes

--4"3000 TSoO (Gas)

T705 160 128M rr. axle 22000 T700 -'fg54 160

-- 41000 T850 162 130M rr. axle .33000 T700 61/63 A/brakes

-43000 Ts50 ((jas)

3U M rr. axle ---" ---_ .. _- -

45000 t.r850-~-T700 16u 1 33UUO T7UU T855 60 61/63

-------45000 TS50 (Gas)

T.2!Q 57/59 122000 T70u 43000-T720 :>tI/:>9 32000 T700 T856 60 T850~----

T74U atl/:>9 32000 T700 62 j27000 TS50

~:3.. 49000 T850 (Gas) T750 57/59 37000 T750 ~tI ,ou 134M rr. axle

--

45000 TS50 60/62 35000 T750 T80U j:>8/09 137000 TS50 03 37000 T7:>U ~8~ ~8/59 ---- .-------~~- --

300UU TS:>U

T751 60/63 27000 T70U T880 158/ 59 Hyd/brakes 143UOO TSoU -~

T752 60/62 :rmoO T750 TS90 158/ 59 Hyd/brakes 145000 T8:>u

63 39000 T750 T950 158/ 62 46000 T950

T753 ,63 41000 T7:>U 163

r---~-- --- ._-- - --14700U ~~i~~G~~Ln

T755 162 30M rr. axle 37000 T750 ;1'91>1 10u/m- 32"000--

T750 10", 39000 T750 103 30000 T9:>u (Gas)

T750 ------_ .. _-

48000-1'f9~---T757 162 41uOO 1952 160/ 02 T760 157/ 59 ,27UUU T750 63 49000 T950 (Gas)

T953 61/62 -~--

51000 T950

T800 157/ 59 f'\./br~ 43UI)U_ TSOO T904 ~~- ---------- ----

53000 _~~;~lG~~ _ 60/62 '39000 TSOO TIOOU-

63 ~yd/brakeS 143UUU TSOO 62 --30000 T950

---rsO(}OO

03 ]"0000 T950 (Gas) T8Ul OU/O", ~OM rr. axle TSOO

03 --127000 TSUO T955 03 59000 T95U (Gas)

T802 oW 0", 41000 T800 T956 63 --~ T950 (Gas) 03 jA/brakeS 143UUU T800 1'957 63 -170000 T950 (Gas)

---------

TSOO T8U3 '~ 30M rr. axle 450uu T960 :58/59 9M frt. axle 132UOO T950 30M rr. axle 43000- TBO-O---- T97U 5S/:>9 4S000 T950

162 34M rr. axle & hyd/brakes 43000 TSUO T980 15S/ 59 11M or 10M frt. axle 32000 T950

163 4:>000 TSOO T990 5S/59 51000 T950

FORD TRUC/( 'ARTS GENERAL INFORMATION

WARRANTY or RATING PLATE - continued

MODEL CODES MODEL YEAR DESCRIPTION 1 G.V.W. CATALOGED CODE RATING AS -

V850 Ss 39000 T850 (Diesel) -

27000 T850 (Diesel) V851 163 41000 T850 Diesel) V852 163

T850 Diesel) va53 V854 V855

V950 V951 V952 U953

W85C W85 W852

63 43000 63 --~OO T850 Diesel)

63 49000 T850 Diesel) ----

163 47000 T950 (DiM(!l) 30000 T950 (Diesel) 163

163 49000 T900 (Diesel) --

53000 T900JDies~ 163 -1----

163 39000 NT850 (Diesel)

163 27000 NT850 (Diesel)

163 41000 NT850 J.DieseU ----

--

DATE CODES FROM 1957 TO 1960 A BUILD DATE CODE WAS SHOWN ON THE WARRANTY OR RATING PLATE.

THE DAY OF THE MONTH IS SELF EXPLANATORY.

THE MONTH CODES ARE IDENTIFIED IN THE FOLLOWING CHART.

MODEL YEAR DESCRIPTION CODE

W853 63 W854 163 W855 163

W95u 163 W95l 163 W952 163 W953 63

YUUU 51/52 j53

YOOI 151/ 53 Y002 153 Y950 161/ 62 Y951 101/ 02

~O2 101/ 02 -----

._-- ------- ------ -------- ------- -_. ------

.~.\ .. ~ Of D.~: \j.S .... ~ {)Ff.

G.V.W. RATING

43000 45000 49000

47000 30000 49000 53000 - ._------

34000 ~OO 2oUOO 34UUO 32000 26000

~~~

XXIII

CATALOGED AS -

NT850 (Diesel) NT850 (Diesel) NT850 (Diesel)

NT950 (Diesel) NT950 (Diesel) NT950 (Diesel) NT950 (Diesel)

HlOOO (Diesel) HlOOO (Diesel) H1000 (Diesel) H 1000 (Diesel) H950 (Diesel) H950 (Diesel) H95(} (Diesel)

CODE CODE MONTH

CODE MONTH COD E I MONTH

1st YR. 2nd YEAR MONTH 1st YR. 2nd YEAR 1st YR. ! 2nd YEAR 1st YR. 1 2nd YEAR·

A B C

N January D R April P February E S Mav Q March F T June

AUXILIARY TRANSMISSION CODES

G U July K H V August L J W September M

-----._-------------------------------------------------_._----.--.

~" .~ D t: ~ N (:::!~""".... ~~. R t: C;. u. s . ,.;s ~ ~'"

U . S .. ~. i} '{ {'+.t~:.(:}:;C'{..:1. .. P A -r () f: i; .

D.,~TE TRANS, .. AXtE

THE FIRST DIGIT OF THE TRANSMISSION CODE INDICATES ~:::::::::JST ____ ... ~~:::::::::_~:~:~~:::l 0 THE TYPE OF AUXILIARY TRANSMISSION.

THE FOLLOWING CHART LISTS THESE CODES, THE NUMBER OF FORWARD SPEEDS AND THE MANUFACTURERS NAME AND MODEL NUMBER. : :

X October Y November Z December

CODE YEAR SPEED MANUFACTURER

CODE SPEED MANUFACTURER

NAME MODEL YEAR NAME MODEL

1 60/ 3 Spicer 5831-C 7 58/59 3 Spicer 5831-C 2 60/ 3 Spicer 51l31-D 61/63 3 Spicer 8031-G

3 60/ 3 Spicer 7231-B 8 58/59 3 Spicer 5831-D 4 60/ 3 Spicer 7231-D 63/ 4 Spicer 7041

5 60/63 4 Spicer 1l341-A 9 58/59 3 Spicer 7231-D 63/ 4 Spicer 8341-C

6 58/59 3 Spicer 7231-B Q 51l/5\! 3 Spicer 5831-B 61/ 3 Spicer 8031-C R 58/59 3 Spicer 7231-D

z 59 4 Spicer 8341-A & C

XXIV GENERAL INFORMATION FIJI' ""CIl P"'S

WARRANTY or RATING PLATE - continued --------------------------------------------------------------,

MAIN TRANSMISSION CODES '" ,"~;-~;--;~--:~~~;~~~~::::~--~:-~-1~-~;~--~::-:-~:--[ i u .~,.".A •. ~1~ "~_': ~~~.~'",,'tJt.~l ... P<l/\ .. T __ ~,;:-(-;,., ~.,"".;.:-" ,,::,: ,,::::

~".~~;~ TR.,~\N$ .. ,~\Xtt ._----------------------------------------.----------

.~ , ... '" l~~ ~ it--: THE SECOND DIGIT OF THE TRANSMISSION CODE INDICATES !;) I.. .'t~ {~<,.;;.~ : 'j: : THE TYPE OF MAIN TRANSMISSION. --------------------------------------------------------------, j !

THE FOLLOWING CHART LISTS THESE CODES, THE NUMBER OF FORWARD SPEEDS, TYPE AND THE MANUFACTURERS ,::::: ':;:: NAME AND MODEL NUMBER.

Also refer to Auxiliary Transmission Codes on the preceding page.

MANU FACTU RER CODE YEAR SPEED DESCRIPTION r---,NC"'A-:-:M-:"C

E=---,-----,-:----

A-- 57/ 3 Manual --'FOrer-61/ 5 DireCt----+=Fo-'u"'ll·e-r~----+==,.,-----

_A_u_t-,-o,-. +5_7_+---=-3 ----f_Automatl c Ford

B~--j-,5:-;:7;-c/----j--03-j-O~v-erdrive Warti.-cercc----t=-=--=""-

__ ~_+6:..:1"-/-l....c:5-j-O=-v.c-e=-:r'-'d:.::.r-'-ivc.:e--- ~p_t_c_er _____ -+ __ __'___'__

c

D

Automatic -- c-Fo-C-:r-:-:d,--~-~----jr..-,..~~­~"T-Oj-=--+':;

Direct~ Splc-,-e-,-r~~~~+,-,-,,-_~_ 57/61 3 61/ 5

------- Warner r.'"----+-~+-D...,irect -= F'-'u--cI'I~e~r~~-~+"~7'--"'-'-=--57/ 3 61/ 10

57/ 3 -' ---__+c-::-----j--=---1~ .... -- -.------E f7'-'--;---+--",-::+,,,, .. ____ VJ_a,=;r~n~e_r~~_~E--:--'-'~=-_

61/ 10 __ ~____j~~+_~~D~i~r~e~c.t~------F----ul-l.e~r~~~--_r~~~-

57/ 4 63/ 4 ~_ .. ____ ~~~=1=~=~;~t~~f~~~~:f ~"a~:-:a:::-::c:-::·~~a-m=--~~-+-~-~-

G

H

57/59 5 60/ 3 61/ 10

Overdrive --c-N·e'c:-w---.-:Oc-r-:-oc-:-e-s-s-~--+""547C0;;--~~­~~+-~~A-utomatic -- ~F~o·~rd'---~~~+'M~X~----­

~~+-~+.O-'verdrive-- - F:-:-u"1l-er--~~~---+'R"""A.---c-9;;-;S"0---

5"I/ot! 0 I uirect 'ClarK or 25UV *New Process 540

I-:-:--:--t----o--t,:::--· ---.. --;;---~____jri<6_o,O~/__+___o__6nc::T'"'rc."a=nsmatic Allison MT-30 I ~ __ 1Q.. Qverd2'i.ve __ Fuller:.. _______ ~. __

T--Ws9 5 Overdriv-e-- Clark 265VO 60/61 5 Direct-- 'c"'la::-:r::Tk:---------t-;.2'"5"OV..,-----

+';16"'2'--'--'+---;'-5---f-...ID'·'i·:r~~e'-"cC - --TCIark~0;-;;rc----t1"'2~5--=UI'V,..---*N,,,w Process N5A, N5B

_ . __ 1.63/ 5 'Direct ____ ·+-C"'loc-8._r_.-k _____ +2"'5 .. 0"V.-__ K 57/59 5 Direct Clark 265V

'60/61 5 OverdriVe -- Clark· 265VO ~. ~ OveiiITTVe--- *Claik-o~-::-r------h2'11"!5-i-1..--rn: VO--

*New Process N5C, N5D 63/ 5 OverdrtveClark 251VO

L 57/59 5 Direct- -SpTc--:ceccr~--~~+4"!6"'!5"2---~~ reo-'--~- Direct .. -- clark 265V 61 5 Dire·ct---- Clark'~~ 2651-V1,

2653-V1 IB2 5 IDirea--- -*cra-oorr.-K----n12"'OiCF<!51--,..VT<1'--,-or 2653-Vl

*New Process N5G, N5H 63/ 5 Direct------ Clark 2651-Vl,

~----+=-c=_._l~---+~.--~ .__ _ r;-::c.-:--:-::--___ +2,,6ci-5"'3_-V--,l:........._ M 57/59 5 Direct Spicer 4652

160/61 5 QverOrlve- - Clark--- 264vO i1'lo"'2----t--,o,---+.lu"'~'v-ercrrive- TChco;r-r.-K---;;0C;:;-r--~--io2".,..-;r04T17'<V'O--

*New Process N5J, N5K rs3T -~ ()veicfr\ve---- cfa:rK ~----t.2""'6'4~VIO--

--c----- c---- -- .. - - --- --~-__+~--~-

YEAR SPEEDI DESCRIPTION I MAN U FACT I U R E R ~I_ I NAME MODEL

57/59 6 Transma:rfclAffi~ MT-30 160/ 5 Direct . - !sPtcer 5652 161/ 12 over<lrfVe -- Sptcer 8125 58[59 8 Roadrangel= Furrer--· R-45 Jl9L o~ pired__. Spicer 5"15t5-Jj ~8/59 5 Direct Spicer --- 5756-C 60 5_ Direct -- SpTcer-- 5756-B 61/ 5 Direct -~-=-J-Spfc~r .---. tJ:Jo2 ~60 5 Dire~_ !sPicer 0352 W 5 Dir~t _~=-[sPic_er. o1J52-G 58/59 5 DireCt __ -- "Spicer o1J52-G

160/ 5 Overdrive-~-icer ! 0453-A ~59 5 Overari~-=:= sprcer--- 6453-A ~r 1J Roadranger Tiller . R-46 57 b Uirecr- 'ClarK or 20UV

*Nf'W Process 540 -u----t~6tr'1I-.. +_l5:-..+_D~irect Spicer 6352-B

57 0 uirect --~ ~K or 20UV

W

x y

z

*New Process 540 59 5 Dfrect-·----.~;Picer 5652 rsv- 5 Direct Spicer 5452-A 57 5 Dtrect-- -Clark 265V ~-__ ~ DilliL ______ ~!c:er . 5756-B 61 f> Direct Clark 2621-Vl.

2622-V1 Direcr----- ,.L1arK-------I-i2:;.;5)~:211 ~_ v:r.1i---,-

or 2622-Vl

'63::--/--:----J-5-:C--+--nCtre-c-t- ---.-.-*New Process N5L, N5M clark---- ----+2~6~2-1·--V-l-,-

2622- Vl 57 5 Direct .- CTirJ{ 265V 59 3 ktitOmarrc-- Ford F /M 57 5 Direct --spiCer 4652 61/ 5 Overdrive--- SpTce-r--· • S055-A, C 57 5 Direct-- Spicer 4753-A 61/ 5 Direct -- S·ptcer- ! 8054

~162/ 0 Transmatlc- Jlmson ,MT-;m--3 57 3 IManuar----· "Ford _ 6.2L 6 TransmaHc- AfTison- -- -- f~,'fT--:'~-

~l:I_D _ 5~ --~3 Manual - -- -- -Warner--- - T87E _~L~_~·~':3- M-alluaJ ~- Ford - -=: ---1--- ---- -

3MD 57 ___ ~- ~_~_nua~_.__ __ Warner -~ T8~C--- -J 62/ 5 Direct Spicer -----6'3·5~4~-~ 4SPD 57 4 Synchronlzed Warner T98A 5 !52/ 5 Ove~dri~t?--=---:-Spicer . 5455-A 5MDD 57 5 ,DireCt "CElrKo'r !4~UV

"New Process 540 5MDO 57 5 "Clai'kor- ·-~fV(J---

"New Process 540

~--~;>--r-i-- ~i~!~- --.. -~~:f~~==-' --.-1 ~~t~ -~ 152/ 5 Dtrec-t ----- rsPicer----~~~

* Alternate in production - refer 0 Transmission dentuication :hart a the beginning Of ~ection 7 for complete identification.

1f1RD TROCK PflRTS GENERAL INFORMATION

'l..XV

WARRANTY or RATING PLATE - continued

REAR AXLE RATIO CODES

THE FIRST 2 DIGITS OF THE AXLE CODE IDENTIFIES THE RATIO and/or CAPACITY OF THE REAR AXLE.

$~ X Lt: - -

.~ .~) t U{i--:C) I! THE FOLLOWING CHART LISTS THESl CODES AND THE CORRESPONDING RATIO AND/OR CAPACITY. FOR FURTHER IDENTIFICATION REFER TO SECTION 40.2 IN THIS CATALOG. i i

1957/59

A X L E RAT 1(\ conF 1-

A X L E RAT 10

~l·-- . f -- -_.--- ~

1957 I 1958 I 1959 19S7 1958 1959

01 3.70 3.70 3.70 41 5.83/8.11 H/D 6.80 J11M) 6.8u (11M) 42 6.33/8.81 H/D 6.8lJT13M) 6.8u (13M)

02 3.89 3.89 3.89 43 6.80 (14M) 6.80 (14M)

03 4.11 4.11 4.11 04 4.56 4.56 4.56 44 6_ 80 (15M) 6.80 (15M)

51 7. 80 with H/D 5- 83/8. 11 (13M 5.83/8.11 (13M) 05 4.86 4.86 4.86 06 4.88 4.88 4.88 Front Axle I

8. 60 with H/D 5 83/8. 11 (141',10 5.83/8.11 (14M) 07 5.14 5.14 5.14 52

5.83/8. 11 (15M~ 5.83/8.11 (15M) 08 5.83 5.83 5.83 Front Axle 53

09 6.20 6.70 6.70 61 6.33/8 81 (14M) 6.33/8.81 (14M)

10 6.70 7.07 62 6- 33/8 81 (15M) 6.33/8.81 (15M)

11 6.80 7.17 7.17 71 6.50/8.87 6.50/8.87

12 7.07 7.20 7.20 72 6.50[9- 04 6.50/9.04

13 7.17 7.67 7.67 7.79 (22M) 7.79 (22M) 73 7:T779.77 7.17/9.77

14 7.20 80 6.50 6.50 15 7.67 7.80 7.80

81 6.69 6.69 16 7.79 8.60 8.60 82 5.85 5.85 17 7.80 7.79 (28M) 7.79 (28M)

83 6.17 6.17 18 860 7.07 (28M) 84 6.67 6.67 19 6.38 85 7.03 7.03 21 5.83 B/D 86 8.38 8.38 22 6.20 H/D 87 7.60 7.60 23 6.8U H/D 3.73/1 L/D 88 5.57 5.57 24 7.2U H/D 3.92/1 L/D 89 5.43 25 4.88/1 L/D 90 6.14/8.36 6.14/8.36 26 4.56 L/D -----gr 6.71/9.13 6.71/9.13 31 5.83/8.11 6- 20 (11M) 6.20 (11M) 92 6.42/8.38 6.42/8.38 32 6.33/8.81 6.20 (13M) 6.20 (13M) 93 7.09/9.07 7.09/9.07 33 650/8.87 6.20 (14M) 6.20 (14M) 94 5.57/7.60 34 6. 50/9. 04 6.20 (15M) 6.20 (15M) 95 5.43/7.39 35 7.17/9.77 99 Special Axle

------ - ---------

1960 c c c c 0 0 0 0 0 TYPE AXLE RATIO 0 TYPE AXLE RATIO 0 TYPE AXLE RATIO 0 TYPE AXLE RATIO -~- - -- - ----0--

5.83(13~-_.L ------:--"7: 79 (28M)

E E -6'.50/8.87 (18M) B1 1·speed G3 1-speed 07 Regular 5.14 54 2-spee~_

132 l::speed ~-:-20 (T3M)-- K2 l-speed 6.20 (14M) 08 Regular 5.83 55 2-speed 7. 17/9. 77(18M) B4 l-speed f-~ •• ~o..(13M) ___ K4 ~s~ 6.80 (14M) 22 1-speed 6.20 (11M) 56 2-speed 5.57/7.60 (18M) C1 ~-spe~~ 4.88 (21M) Nr 2-spee~_ 5-:8-3/8.11 (15M) 23 1-speed 6.50 (16M) 61 2-speed 4.88/6.33 (23M)

C2 1-speed ~-7 (21M) N2 2-speed 6-:-33/8.81 (15M) 24 1-speed 6.80 (llMj---62 2-=5pe-ed 5.43/7.39 (23M) C3 1-speed 6.5~lMl_ S2 1-speed 6.20 (15M) 25 l-speed 7.17 (16M) 63 2-speed 6.14/8.36 (23M) C5 l-speed 7.17 (21M) 84 1-speed ~80(15~ -32 T-SPeed 5.57 (18M) 65 2-speed 6.71/9.13 (23M) D4 1-speed- 6.38-(29M) --- 56- i--speed DO-(15M) 33 l-speed 6.50 (18M)-- f-rl l:Speed 6.70 (22M)

-:66 I~sp~£ 7.03 (29M) -eJf.- Lock -- 3.'73---35 1-speed 7.17 (18M) 73 1-speed 7.79 (22M)

ET 2-speed 5.8378. 11(14M} OEf LoCk--~ 3.92 37 1-speed 7.67 (18M) 81 1-speed 4.56 (34M) E2 2-speed 6.33/8.81 (14M) . uD Lock 4.56 41 1-speed 4.88 (23M) 82 1-speed 5.85 (34M) E4 2-speed 6.50/8.87 (21M) OF Lock 4.88 42 1-speed 5.43 (23M)

--83 -l::speed 6.69 (34M) E5 2-speed 7.17/9.77 (21M) 01 Regular 3.70 43 1-speed 6.17 (23M) 84 l-speed 7.80 (34M) E6 2-speed 5.57/7.60 (21M) 02 Regular 3.89 44 1-speed 6.80 (23M) 85 l-speed 8.60 (34M) E7 2-speed 4.88/6.65 (21M) 03 Regular 4.11 45 1-speed 6.67 (23M) 92 i-speed 5.57 (38M) F4 2-speed S-. 42/8. 38 (29M) 04 Regular 4.56 51 2-speed 5.83/8:11 (13M) T3 1-speed 6.50 (38M) -- ---''- 7.-097g:07129MT 05 f-Regular-~86 F6 2-speed 53 2-speed 6.50/9.04 (16M) 95 1-speed 8.38 (38M) ---.--"r.07(28M) - OIl' G2 1-spee~_ Regular 4.88

I--

XXVI GENERAL INFORMATION

I(JR/) TRUCK PARTS WARRANTY or RATING PLATE - continued

REAR AXLE RATIO CODES

1961/

(A chart covering 1961/ Rear Axle Ratio Codes is included in Section 40)

----------------------------------------------------------""l --------------------------------------.-----------------I i

l\~' .~ n t: f N ,::~~~""".. • .. R t: (; \J . 'S. 1 ! FRONT AXLE CODES "," -i! "' ... ·l .... ~~" .. y "

\.1 . ~i. A. 13 '{ ~~.{,.~ l~t.(.·, P.'" T. 01' f . I::,':::, ::,:::::,

t'J .• t\H H~.AN5. AXtE

THE THIRD DIGIT OF THE AXLE CODE IDENTIFIES THE RATIO .:I~f::::: ... :~~:~~···.:::::.I~@:j (~) and/or CAPACITY OF THE OPTIONAL FRONT AXLE. iii: iii,'

THE FOLLOWING CHART LISTS THESE CODES AND THE CORRESPONDING RATIO AND/OR CAPACITY. FOR STANDARD AXLE INFORMATION REFER TO SECTION 30, PAGE 1 IN THIS CATALOG.

1 !

COOES ! RATIO OR CAPACITY - CODES I U RATIO OR CAPACITY CODES RATIO OR CAPACITY CODES RA TIO OR CAPACITY

1957/59 1960 1961/63 1961/63 - continued

A 3.92-3M A 3.92-3M A 3.92-3M F 9M-1961/62, [5. 5M(light & med.} or 9Mwjo H/Dfrt.

B 4.55-3M B 4.55-3M B 4.55-3M brakes (hvy. H963]

C 6M C 6M C 6M G 11M

F 5M & 9M D 5M &7M D 4.55-3.5M H 15M

G 11M E 5M &9M E 7M-1961/62, [5M(light & M H,!b Frt. brakes -std. axle ~-

med,) or 7M (hvy,)-1963J H 15M F 11M 0 9M & HID Front Brakes

.~~--

----

G 15M

DISTRICT CODES

CODE DISTRICT CODE DISTRICT CODE DISTRICT CODE I DISTRICT

11 Boston 28 Louisville 46 Indianapolis 71 Los Angeles 12 Buffalo 31 Cincinnati 47 Cincinnati 72 San Jose 13 New York 32 Cleveland 51 Denver 73 Salt Lake City 14 Pittsburgh 52 Des M::>ines 74 Seattle

33 Detroit 15 Newark 34 Indianapolis 53 Kansas City 75 Phoenix 16 Philadelphia 35 Lansing 54 Omaha 81 Ford of Canada 17 Washington 36 Louisville 55 St. Louis 83 Government 21 Atlanta 50 Davenport

84 HomeOffice Reserve 37 Buffalo 61 Dallas

22 Charlotte 38 Pittsburgh 85 AmericanRed Cross 23 Philadelphia 41 Chicago 62 Houston 86 DIPLOMA.TIC SERVICE COMM.

24 JacksonVille 42 Fargo 63 Memphis 89 TRANSPORTATION SERVICE

25 Richmond 43 Milwaukee 64 New Orleans 90's Export 26 Washington 44 Twin Ci:ies 65 Oklahoma City 27 Cincinnati 45 Davenport

FDRD TRUC/( 'ARTS WARRANTY or RATING PLATE - continued

BODY TYPE DESCRIPTIONS

GENERAL INFORMATION

(Arranged in Alphabetical Sequence)

Most body parts and some chassis parts are listed according to Body Type. For example 81,83 etc. From 1957/62

this information did not appear on the Warranty or Rating Plate. From 1963 certain body type information was

shown on the warranty plate. Exceptions to this were back-of-cab eqUipment: pickup boxes 83 and 99, platforms 80;

and racks 86.

The body type suffix such as (89)A, (89)B, (89)C etc. is not shown on the Warranty Plate. To determine the specific

body type through warranty plate information the model code such as EllO, E360 etc. must also be used.

A chart listing the body type codes in conjunction with the related model codes is shown on the following pages.

BODY TYPE CODE SHOWN IN CATALOG

XXVII

DESCRIPTION

~57!6~_I_B2961/62 hnn- -riW/IIOJ)---------Conventional Closed Cab-Custom 81B 1B B F-T Conventional CloseQ Cab-Standard -BfA !llA !llA J,F-TIUU/ lWU) Closed Drive Away-includes- Windshield Frame 85 85 85

_._-- t--. -Econoline i>lckup-(Custom) 87B

Econoline Pickup (Standard) 87A 87A Econoline Van (R. H. Fixed Window) 89E

Econoline Va-ri (leI{ and L_ H.-FIxed Windows)---- --------- -89F

Econollne Van (R. H~andL. H. Doors) ~---------~-- --------- --t------.-

89G Econo1ine Van (Standard) 8SA 89A

._---------------,. .- --F alcoi1De iuxe-Club Wagon 89D Falcon Station Bus

-_.

8gB 89B -F'alconStationBus(C-ustomj--- -------- -- - 1-- -

89C

--- --Forward Closed Cab-Custom 8lB (N-NT500/1100) Forward Closed Cab-Standard 8lA (N-NT500/1100)

-------- -- - -

Hi-Tilt Cab 91 91 (H-HT950/1000)

-----Integral Cab and Pickup Box-Standard 66A 66A Integral Cab and Pickup Box-Custom

- - -66B 66B -_.--

Open Drive Away-less Windshield Frame 84 ._-

-84 84 ._--

--_. -- --r---Panel Delivery-Custom 82B Panel Delivery-Standard

--_. 821\------_.-

---~ --:-- ---

Parcel Delivery 85 85 85 -----

--"---

Pickup Box-Flare Side 83 83 83 Pickup Box-Style Side 99 99 99

---t-PlaUorm !!U 80 80

------- _. Rack 86 86 86

- - --

Tilt Cab-Custom 9lB 9IR --_ .. _-

t-glB (C-CT500/1100) Tilt Cab-Standard 91A 9lA 91A (C-CT500!1100)

XXVIII GENERAL INFORMATION FDRD TRUC/( 'ARTS

WARRANTY or RATING PLATE _ continued

BODY

BODY TYPE CODES

1963 ECONOLINE

(From Serial 325.000 thru 444.999\

USE TWO DIGIT BODY TYPE CODE,

FOR EXAMPLE', . . . . . . 89

IN CONJUNCTION WITH MODEL CODE

FOR EXAMPLE: . . . . . . E 130

TO DETERMINE CATALOG BODY TYPE DESIGNATION

IN THIS CASE "89D"

TYPE MODEL DESCRIPTION CATALOGED AS-

87 E103/E104 Pickup (standard~~~-,-~_ea_vy_D_~ty ____ ~ __ ~ __ ~ _______ . ____ ~ __________ 1----.?7A __ _

E103/E104 Pickup (Custom)-Heavy Duty 87B

E150 Pickup (Standard)- Heavy Duty 87A +-------11__- -------------. --------~---~--------------------_---~-'-':---

E150 Pickup (Custom)-Heavy Duty 87B

--_l-------c~--------~----------- -- ---------~-----------------t__~---~----~I------+------------------------------~---------_l------

89 Ell0 Station Bus (Standard)-exc. Hea vy Duty 89B

E120 Station Bus (Custom) 89C +__----+-------'------~- ________ ~ __ ~ ___________________________ +_--.:c"--~~-

E130 Club Wagon __________ ~ ______ ~. __ ~ ________ ~ _____ __j--~8~9D=--

J-E.:::.l_43,-,-/_E_l_4_4 _-l_C_a_r.::::g_o~_ '1~~~~~I!~b~~d!_~~~r_~_ (less Win~S)~~xc~H~~PE~ ______ ~ ____ ~ __ -J--__ -=8:9.,A

E143/E144 Display Va-n-with R. H. body side doors and windows-exc. Heavy Duty ------ ----- ~--- -~----~-- ---~ ~-~~---~~ -~---~. ~----.-~ ~--'----"'--------~-~----

89E

E143/E144 Cargo Van-with R. H. and L-. H. body side doors (less windows)-exc. Heavy Duty +--'-----J---=------ ~---~---- ---------.-

89G

E160 Cargo Van-with R. H. body side doors (less windows)-H:::e::a:..VY:'...::D~u:..::tY~ __________ +--__ ~.::.c89:.:A~ __

89F E160 Window Van-with R. H. body side doors and R. H. and L. H. windows-Heavy Duty e--------- f--- - ~ ~~ ~ -.~-- ~ - - - ---- --------- -~--~ ~ ~~ -------~ - -- ------------- ----=----------+----

E160 Cargo Van-with R.H. and L. H. body side doors (less wtndows)-Heavy Duty 89G I---------f---------~~ ---~.--------- -~--~------ - --~----- ------- -----1- ~--~- ----

E170 Station Bus (standard)~_H=_~eac.vy_=_D_u"'t=y _________________ ~ ______ -I-___ 8,e.::9:=B'---_

~ ~- ------.. -~ ----------- - - ---------------~-----

--~------j------------ - ~- ----- - ------------~-~-----+----

'ORO TRUC/( 'ARTS ___________ ~-=ABBRE VI A TI 0 l'\" S & ••••••••••••••••••••••••••••••• , and fill •••..•••••.•••••••••••••••• fillister 2/B •••••..••.••.•.••.•••....• 2 barrel flng ....•...••....•••.......... flange 3T or 3/SfT ............. 3 speed trans. F/M ••••••••••••••••••••••• Fordomatic 3 or 4/S/T .. ........ 3 or 4 speed trans. frt ............................... front 4/B • •..••...•••••••••.•••••.• 4 barrel ft ••••••••••••.••.•••••.•••••••••• foot 4/W ID • •••••••••••••••• 4 wheel drive f/wheel • •••••••••••••••••••••• flywheel 4 x 2 ..•....•............ 2 wheel drive F Iward ...................... Forward 4 x 4 •••.•• , •...••.•.•••• 4 wheel drive

a/brakes ............................ air brakes gal. •••••.•••••••••.••••.•••.••• gallon gen ••••••••••..•••...••.•.•• generator gov .••••••••••••••••••••••••• governor G. V. W •••••••••••• gross vehicle weight

GENERAL INFORMATION

XXIX

qt .••••••••••..•••••••••••••••.• quart qty ••••••••••••.•••••.•.••••• quantity "R" •••..••••••••••••...••••••••. right rad ••••.•••••.•.••••••••••••• radiator

RIB . ..•................... replaced by

recirc ..••••••.••••.••.•• recirculating reinf. •..•••.•.••..•••••• reinforcement repl. .•.........•..••....•• " replaced req'd ••....••••..••••••••.•.•. required ret .••••••..•.•••••••.•.•••••• retainer R. H •.••.••••••.••••...••••.• right hand

accel •••.•.•••.....•..••••. accelerator A/C . •••••••••••••••••. air conditioner adapt ••••.••.••••...•••.•.•••• adapter ------------------1 R. P. M •••.••.••. revolutions per minute adj •.•••••••.•...•• adjusting-adjustment alum ••.••.••.••..•••...••... aluminum amp ••.••••••••••..••...•..•••• ampere approx. • . • • • • • • . . . . • . . •. approximately AR •••••.••.•.••••••..••.•• as required

assy ....••...•••...........•. assembly aux ••••.•••••••..••.•••.••.•• auxiliary

BBC ............. bumper to back of cab brg ••••••.••.•.•.••.•••....••• bearing brkt •••••.•.•..•••.•••••••.•.•• bracket

C4 ..• (TRANSMISSION) ••• 3 speed dual range cap •••.••••••••••••.••••.••••. capacity carbo , •••••••••••••.•••.••• carburetor

C/F • •••••••••••••••••• '" .cab forward Chg/L ..•••.••........... change level c/member ••..••••.•••.•.• crossmember conn .•••••••••.•••••••••••• connection Conv ..................... Conventional cov., cvr ...•.•..•..•..•••....•.. cover CPo •.•••••••••••.••..•.• candle power

c/P/s ........... Center point steering c/pin •••••.••••.••••.••.•••• cotter pin c/shaft ••••••••••••••••••••• crankshaft ctr .••.•••••••..••••.•••••..•..• center cyl •••.•••••••.•...•....••..•• cylinder

D/4/S • .•••••••.••• , Dagenham 4 speed DID • ••••••••••••.•••••••• direct drive defl. • • • • • • • • • • • • • • • . • . • • • • •• deflector dia., diam ••••••••••••••.••.•. diameter diaph •••.••••••••.•••.•••.•• diaphragm disp ••••••••••.•••••••••• displacement dist .•...••••..•••••••••••.• distributor

D/R .... .............................. Delco Remy drld ........................... drilled

ea •••••••••••••.•••••••••.•••.••• each E/H/D • ............... extra heavy duty em/re •••••••••••••• emission reduction eng •••••.••••••••••••••..•••••. engine exc ........................................ except ext •••.••••••••....•.••..•••• extension EI susp. (It. wt.) . . EATON SUSPENSION (ltolrt _Iolrt)

ev/em •••••••••••• evaporative emission

F2, F4 .............. Ford 2 or 4 barrel F I A, F laxle .............. forward axle fdr •••.•••••..•.••••••••••••••.• fender

HI, H2, H4 ........ Holley 1,2 or 4 barrel hd •••••••••.••.••••..•••..•••.•.. head H/D .•••••••.•••••..••.••••• heavy duty hel •••.••••.•.........••.•••... helical hex ••••••.•.••••••••••••••••.• hexagon H/D R/R ••••••.• heavy duty roadranger hsg ••.•••••.•••.•.•••••••••••• housing HI susp.. . • • . Hendrickson suspension H/V •••••••••••••••••• hydraulic vacuum hyd •••••••••••.••••••••••••• hydraulic

I. D •••••••••.•..••••••• inside diameter

I/K .........•......... Inclined kingpin instr .. instru •.•.•••••••••••• instrument inter ••.•••.••...•••••••••• intermediate

"L" •••••.••••.•.••••.•••.•.••..•• left lb •••••••••••••••••••.••••••..•• pound LID • •••••••••••••••••••••••• light duty L. H •..••••••.•.•.•••••••••••• left hand LHD ••••••.••••••.•••••• left hand drive lub .•..••••.•••••••••••••.•. lubricator l/w, l/washer .•••••••••.•..• lockwasher lwr •••.•••••••••••••••.•••••••.• lower LIN ............................... Leece Neville

man ••••..•..•••..••..••.•.••• manifold

MAID. .•...•............ Maximum duty MID • ••••••••••••••••••••• medium duty m. m •..•••.••.•..••••.•..•• millimeter

M/S .............•.... manual steering mtg .••••••••••...•••••••••••. mounting mtr •.••••••••••.••••••.••••••.•• motor

No .•••••••••.•••••••.••••••••• number N. P.G •• ............ New Process Gear

O. D .••••••••••.•••••• outside diameter OlD .•••.•••..••.••••.•••••. overdrive Oper ......................... operated O/S •••••••••••••••••••••••• oversize

park ••••••.••••••••••••••••..• parking pass •••••••••••••••••.•••••. passenger pes •••••••••••••••••••••••••••• pieces P/D .................. Parcel Delivery p/S •••.•••••••••••.••.• power steering P. T. 0 .••.•••..••••••.• Power Take oft P & PI susp. . . . Page & Page suspension

rr •••.•.••••••.••••••.••••••••••• rear R/R ••••.•••••••••.•.•••••• roadranger r/wheels ••••••.••••••••.•• rear wheels

SIB •••.•..•..•••.•.••••.••. school bus second ••••••••••...••••.•••• secondary s/member ••••••.•••.•••••• sidemember

Ser .. '" ....•.....•.•......•.. serial spec •••.•••••.•.•••.••••.•••••. special S/E, Spec. Econ ........ Special Economy speedo. . • • . . . • • • • • • • • . . •• speedometer spg ••....•.••••.••..••••••••.•• spring sq •..•••.•....•.•.••...•••.•••• square siring .•.•••..••.•••.•••••.•• snap ring std. • • • . . • . • • . . . . • . • • • . • . • • •• standard SIT • •••••••.••••• standard transmission suppt •..•••..••.••.••.•.•••••• support syn .•......•.••.•..•..•.••••• synthetic

T I A ••••••.•.••..••••••.••• tandem axle TIC, T/Cab ................... Tilt Cab TIE . ••••• THERMACTOR EMISSION CONTROL SYSTEM

TIM ••••••••••••••••••••••• Transmatic trans .•......•.•...•.••••• transmission Tron$/lgn or Trans.ign • • • • • • •• TRANSISTORIZED IGNITION

T. S. L •••••••••• Truck Specification List T Isusp. (It. wt.) .. TIMKEN SUSPENSION(ltolrt _IOIrt)

TIT . .................. Tractor Trailer

U. D., U/D ••••••••••••••••• under drive UBS ............. uniform bearing stress ufjoint, u/jt. ••..•.•...•• universal joint l,J IS ........................ undersize

vac •..••••.••••••••••.•.••••••. vacuum vent ..•.••.••••.•••••••••••• ventilation vlv ..•..••..•••••.••..•..••••.•.. valve

wi ............................... with w/b, W/B •••..•.•..•••••.••• wheelbase WiG .................... . with governor w/out, w/o .................... without w/s, w/shield •••.••••••••••• windshield w/strip .•..•...••.•...... weatherstrip

X ••••••••••••••••••••••••••• exclusive X/C . •.••...•.••••••••••• extra cooling X/H/D .•••.••••••• exclusive heavy duty X/H/D R/R ••• EXCLUSIVE HEAVY DUTY ROAORANGER

xxx GENERAL INFORMATION

80 (PLATFORM)

81 (L·LT SERIES)

FOlD TRUC/( 'ARTI BODY TYPE

66 (INTEGRAL PICK UP)

(1961/63)

81 (F.T SERIES)

81 (LN.LNT SERIES)

86 (RACK)

P.4881

P·7503

FORD TRUCr 'ARTS

BODY TYPE

82 (PANEl DELIVERY\

::::::==7;~~~~~~ (1957/601

82A (1969/1

82B (1969/1

82C (1969/1

GENERAL INFORMATION

XXXI

P-7501

XXXII GENERAL INFORMATION FORD TRUC/( 'ARTS

BODY TYPE

84 (OPEN DRIVE AWAY LESS WINDSHIELD)

85 (OPEN DRIVE AWAY INCLUDES WINDSHiElD)

85 (PARCEl DELIVERY) 99 (STYLE SIDE PICK UP)

87A (STANDARD)

(1961/67)

87B (CUSTOM) (1961/67)

89A (1961/67)

F'RD TRUC/( 'ARTS

80DY TYPE

89A (1969/)

898 89C

(1961/67)

898 (1969/)

89D (1961/67)

GENERAL INFORMATION

XXXIII

XXXIV GENERAL INFORMATION

F'RD TRUC/( 'ARTS

BODY TYPE

89D (1969/)

89E (1963/67)

89E (1969 f)

89F (1963/67)

89F (1969f)

BODY TYPE

89G (1963/67)

89H (1963/67)

GENERAL INFORMATION xxxv

P-7504

XXXVI GENERAL INFORMATION F'RD TRUC/( PARTI

BODY TYPE

89J (1965/67)

89K (1965/67)

89l (1965/67)

89M (1965/67)

89N (1965/67)

P-4884

llJRD TRIJCI( PARTS

BODY TYPE

89R (1965/67)

89S (1965/67)

89T (1965/67)

91 (C-CT SERIES)

91 (H-HT SERIES) (1961/66)

GENERAL INFORMATION XXXVII

P-4901

XXXVIII PAINT SECTION FORD TRue/( 'ARTS

INDEX

Included in the Paint Section are the following:

Paints, Thinners, etc., including Thinners and Reducers Undercoats Rubbing Compounds Putties and Sealers Specialties Black Finishes Engine Reconditioning- Paint

XXXVIII XXXVIII XXXVIII XXXVIII XXXVIII XXXVIII XXXVIII

Synthetic Enamels-Exterior Paint­listed by Warranty or Rating Plate Color Code XXXVIII

Appearance and Maintenance Material XXXIX thru XLI

Used Car Reconditioning Materials XLI

PAINTS, THINNERS, ETC.

DESCRIPTION PART NUMBER DESCRIPTION PART NUMBER

IlACK and WHITE FINISHES SEALERS and UNDERCOATS Chassis black-1 gal. can

I B8A 1713-A Lacquer combmahon pnmer surfacer M6J 12-D

(gray)-1 gal. can Lacquer pnmer surfacer (gray)-6 oz. spray MIjJ 12-::)

THINNERS and REDUCERS can Leveler (over spray)-6 oz. spray can B7A 645-8 Primer "ealer (non-sanding)-1 gal. can *AE60 12-A

Lacquer combmation pnmer sunacer (red)- M 6J 13-D Lacquer tlimner No.1 (slow dry)-l gal. can M14J 645-~ 1 gal. can Lacquer tlimner No.! (slow oryj-5 gal. can M14J 645-t; Prlmer-suffacer:':lacquedype (light gray)- M6J -13-E Lacquer thinner No.2 (medium fast dry) - M14J 646-E (light gray)-1 gal. can

1 gal. can Pnmer surfacer (non-salliling flash type)- DL60 13-A Lacquer thinner No.2 (medium fast dry)- Ml4J 646-H (red)-1 gal. can 55 gal. drum Sealer (recoatmgj-for DL60 pamts only- ULIjO 14-A

Lacquer tninner (all purpose)-! gal. can M14J 64~ 1 qt. can

Lacquer tnmner No. 2 (medium fast drYf- M14J 647-E RUIIING COMPOUNDS 5 gal. can Comnound(hand rubbing-water base)-1 gal.can M 3789

Enamel reducer-l gal. can Ii DL60 647-A I SPECIALTIES Enamel reducer (all purpose)-l gal. can M14J 648-D Silicone ~ wax remover-I gal. can I DL60 3721-A

Enamel reducer (all purpose)-5 gal. can Ml4J 648-E Acrvlic lacauer (clead-! at. can AR60 50-C I Solvent retarder (general purpose)_l gal. can .AR60 648-C ENGINE RECONDITIONING - PAINT

EP 1724-C BlacK-l Qt. Silicone Decontaminant (Fish Eye Killer)- AE60 ~-:p;- Corporate Blue-l Qt. EP 2075-C

C o

1 qt. can

o YEAR

E

NAME

* SHOWN ON WARRANTY PLATE

A 57/58 Black A 60/

, EXTERIOR PAINT - ACRYLIC ENAMEL)

PART NUMBER C PART NUMBER

~~ 0 YEAR NAME I~~ 6- 0 3-0Z. 6-~E ~ S S

3-0Z.

~ P ~ P R R A * SHOWN ON WARRANTY PLATE A Y Y

#~E~~ ~~~!_ A c ~ F ~~--- ~l_·g_ht ~ue~~______ ilE60 E~~ <::-~ -- --- G \63/ Chrome Yellow AE60 1526-A C 8

ljih6"'(jL-,-+7fT"u"O:"r-:QUCCCo"i-=S-,,---------+--cA"E"'6"'0cr-55"'6'_-A' f-c ~ --f'-=C---- ----- ---~--------+.c-==-~_~~~--b--+-~ -=:-jf-::-;;:-;--t-=-_=-,-,-____ -----t------- -I--' ~~_ged _______________ ~~?~}~~_~~-_~~-~-=P:..:u=r-"-e-=W-'-'h:.::i:.:.:te::.------______ AE60 1525-A C S ---I--~--l-------------___1

-~~_ ~ .. ::k-G"'r'-'e=-:e:.::n'---------- AE601237-A C S E 57/59 Colonial White M 4J 524- A 8

-+-----~--------- -----M 60/63 Corinthian White DL60 1238- A C S

---1-------1---1-- ~_t.::.::t...::...::__jf=-.-..-c==:....:=::.:-------+=-=::-=--=-=-==-~+__l_~

-- -----t--------------.- ------I----------l--.+-- I--l-----+-------~------- -- ----------I--l----

-t----+------------.-- ------ -- - 1---------- t----I--'- .--I---f------------. ---------.- ----- ----- -----t--t---

-t-----+--------------- --.. --- 1---.-----1---1-- ---1------1------------ --- ----.-- -------- ------- 1---

I!. Used only with DL60 Diamond Lustre or AE60 ·Acryltc paints t Used with AE60 Acryltc Enamel • For slowing evaporating time of Acrylic Lacquer or Enamel Thinners & Reducers. # Also available as M4J 1724-D (1) gal. can

FORD TRUC/( flARTS PAINT SECTION XXXIX

APPEARANCE & MAINTENANCE MATERIALS

PART NUMBER DESCRIPTION

B7A 19000-CS Clear plastic (FoMoCo spraY)-15 oz. net wt. -__ ~~~~ ____ ~s~n~r~a~v~can~ __ ~ ____ ~ ____ ~ __________ ___ _ B7A 19000-DS Chrome-Alum (FoMoCo spray)-15 oz. net wt.­

spray can

--:C~5A,-===Z--,Ic.:9.c0,.:;0.c.0--,-B==-+=C-,-lec-a-cr--ip,-,l,-a,,-s=tic coating-5 gal. can C5AZ 19000:-C Paint (argent lacquer)-15 oz. net wt. -SDrav can

CUAZ; ll:lAOUI-A Rust penetrant & inhibitor-8 oz. can C4AZ 19A501-A Rust penetrant & inhibitor-12 oz. can

C5AZ 19A501-B Parts cleaner-immersion (1) 12 gal. container _______________ -+w __ it_h_1_0--"'g_a_Is: cleaning fluid, (1) dipping basket

C5AZ 19A501-C Parts cleaner-immersion-refill (1) 6 gal. container with 5 gals. clean~_n,,-g_f_lu_i_d ______ __

'C9Az-n~:A5-o1-B- Automaflc choKe- cleaner-:'Cf2) 14oz:spray-ca-ns ~l:IAZ Il:lA503-A Radiator Flush-(lO minute)-(l2) l2 oz. cans

CIAZ 19C507-B Cleaner (convertible rear window)-12 oz. plastic bottle

- ----------------------

C8AZ 19C507-A Cleaner (Automotive Glass) (12) 23 oz.

______________ ~a~e~ro~s~o~lc-c=a~n~s------------------------

B9AE 19B508-A Contact adhesive( gasket & seal) 16 oz. can with brush

tmA ll:ll:Ll::>-A oay unaercoaung-o;:! gallon drum -regular

PART NUMBER DESCRIPTION

BD 19530-A Blue Coral treatment - 16 oz. bottle Custom finish reconditioner-12 oz. plastic

=-c-~-=-=--=-,--+bo-:o~ttl~es B7 A 19530-A Silic-o~n~e-a-u--;t-o-n-o--;l-;-is--;h--"1C:;6;--0-z-.--c-an-------------

B6A 19530-A

B7A 19530-B Custom SilIcone tilOSS (NeW car prepj-l gal. B9A 19530-D Custom finish reconditioner-l gallon can

_C_4_A_Z=--I_9_D_5_3_0_-_A+_L_u_b_r_ic_a_ntJdistributor call1)~l 1E_ oz. tube

BD 19534-A Blue Coral sealer-80 gram jar BD 19534-B Blue Coral sealer-l/2 lb. can

B4A H!5::S"l-A custOm auto wax-8 oz. can B8A 19534-A Custom auto wax I-lb. can

B7A 19542-B Brake fluid (super heavy duty)-l gallon PB7A 19542-C BrakefluicCrsuper hea-vYduty:.5 gallons-----B77i.zT~A--- -BrakeIiiiTdTsuperheavy-dutYj-=T2oz.can:- -C6AZ 19542-A Brake fluid(extra heavy duty)-(24) 16 oz. cans

for vehicles with disc or drum brakes - also

C6AZ 19542-13 -1ii:~:~I~i:~:::;~ ~~~~~ !~~~~-(12) 1 qt. cans for vehicles with disc or drum brakes-also

________________ ~ed as hydraulic clutch fluid

CJAZ; ll:ltiO'l~-A !'Utty.\ctark grayj-1 lb. tube

C3RZ 19C544-B De-icer(windshield)-14 oz. aerosol scraper can

C1lAZ ll:lC::>'f"l-ti lias llne antl-Ireeze-l~ oz. can C'9AZ19C544-A Engine starting fluid-(12) 11 oz. aerosol can C9AZ 19C544-B Liquid tire chain-traction improver-(12) 4 oz. _C=5A=Z:..:1,-,9:.:5:.:Ic::5_-:.:A,---+=Bo~y undercoating-16 gallon drum

aerosol can -C~4~A~Z'I~9--5~1~7~-B~~C~I~0~th~(p~0"li~sLhl~'n~g')---------------------- -----------~~~~-===--------------------------

1A 19517 Dusting cloth (wax treated)-17 1/2" x 23" -gx--TIJ54ti-C l{adiator rust inhiotor lSI; water pump lubricant-16 oz.

C8AZ I9517-A - Thctassy. -buffing-(single) C8AZ 19517 -B Pad assy .-buffing-(duaIHncludes (2) spacers­

buffing pad, (1) 1. S. 3093-instruction sheet

8A 19519-A Cleaner (body pOlish & wax)-1 pint can

B9LF 19B519-A Retrigerant (Air Conditioner)- 15 oz. can

B7A I9520-A Tar & road oil remover-It) oz. can

8A I9520-G Cleaner (body porcelainizeJ.~ 1 gal. can

BAF 19521-A Cleaner(leather and vinyl)-l pint can

B7A I952I-A Spot Rem0ver (chlorothene cleaner) -1 pint can

CUAA II1B5:lI-A -compound (body wash1ngaetergentj--I~ oz. can

8A 19522

B8A 19523-A B8A 19523-B

B8A 19523-C

Bright metal cleaner-l Dint can

Cleaner {all purpose)-1 qt. liquid concentrate Cleaner (all purpose )-1 gal. plastic bottle -concentrate Cleaner (all purpose)-55 gallon drum

CIIAZ; l\ii)2J-A wasll&\VaX concentrate-(4j-Tgal. plastic containers

C2AZ 19C525 -A Trim cement \ v my I adheSiVej-l pmt can

COAZ 19526-A

B7A llli):ltl-A

BA 1\J5;':l:I-B

Triple Clean-for leathers ,vinyls, carpets & fabric upholstries-12 oz. bottle w/brush

I POrCelalffiZe l1qulCI-B oz. oottIes

I Porcelalffize \ wash creamj_-tl oz. batUe

C1AA 19B546-A Lubricant(Hypoid additIVe)-4 oZ.plaStiC bottle C8AZ 19B546-A Adaitive friction mOdifier-hypoid gear-

4 oz. plastic bottle-(for FlOO/350,P350/400, E300 trucks with front driving axles & rear axles with Dana power lock

~HZ; 1I1C::>'1'I -15 Luoncant (std. , 3 & 4 speed trans. J- 5 gal. CtiTZ; ll:lCO'l'I-A Transmission Lubricant-SAE 50 (0 or more

speed trans. )-55 gal. drum

C2RZ 19C548-A Automatic transmission & nower steering sealer-8 oz. can

C5AZ 19E548-A Tinting assort. -(12)-1 pint cans of Acrylic Enamel repair tinting colors

C7AZ 19E548-A Tinting assort. -(12)-1 pint cans of Acrylic lacquer-tinting colors

C2AZ 19549-C

8A 19549-B

CPA 19550-A CIAA I9550-A C3RY.ll:loou-B

C6AZ 19550-A

Ford permanent anti-freeze & coolant-55 gal. drum Ford permanent anti-freeze & coolant-l gallon Ford permanent anti-freeze & COOlant-1 quart

Windshield washer solvent-6 oz. bottle Windshield washer solvent-16 oz. can Solvent & De-icer -w /shield washer-16 oz. glass bottle Windshield washer solvent reserve kit­contains (1) solvent container, (1) bracket & (2) attaching screws

C9AZ 19556~A ~rd ultra clear windshield washer solution­(12)-16 oz. cans

C9AZ 19550-B Ford ultra clear windshield washer solution­(12)-32 oz. cans

I

XL PAINT SECTION FDRD TRUC/( 'ARTS

APPEARANCE & MAINTENANCE MATERIALS

PART NUMBER D E 5 C R I P T I 0 N PART NUMBER D E 5 C R I P T I 0 N

COAZ 19552-A Rubber cement-5 oz. tube (ligFit colored) C5AZ 19579-A Motor oil-10W-20W-30(1 qCcan) 8A 19552-B ,Rubber cement-5 oz. tUbe C5AZ 19579-N Motor Ol1-lUW-~UW~\I gal. canT

CMZ 19579-B Motor oil-l0W-20W-30(5~t.can) C5AZ 19579-C . Mo~r oi!-lOW-20W-:3_0I5.~al._drum) ___ COAZ 19553-A Silicone lubricant (jell type)-Il oz. tube

COAZ 19553-C Silicone lubricant-16 oz. aerosol spray can C5AZ 19579-K Motor 01l-10W-40 (1 qt. can) C5AZ 19579-S Motor oil-10W-40 (1 gal. can) B5A 19554-A Perfect seal sealing compound-carton of 12

4 oz. cans C5AZ 19579-L Motor oil~10W:.I0(5qCcan).- ---.----C5AZ 19579-M Motor 01l-JOW-=.40 (55 _gaJ. dr-urn) COAA 19554-A ,Kadlator mhibitor - rust, stop leaJ{& waler

pump lubricant-5 1/2 oz. bottle C5AZ 19579-G Motor oil-20W -4~ca;:v--

C3AZ 19554-A Sealant-(loctite)-1 2/3 oz. plastic bottle C5Az 19579-R Motor oil-20W-40 (1 gaL can) C5AZ 19579-H Motor 01l-20W 40 (5 qt. can) C3AZ 19554-B ,::;ealer (conductlve)-3 oz. can with brush C5AZ 19579-J Motor oil-20W 40 (55 e:aL drum)

C6AZ 19554-A Metallic Plastic (to repair cyl. front cover & cyl. block intake manifold)(I) can-metallic CIAZ 19580-G Hvpoid gear lubricant (rear axle)-120 lb. keg

resin, (1) jar-hardening agent (S. A. E. 90)-not used with limited slip

C6TZ 19554-A Sealer (gasket and plug) lacquer base-1 pint can (equa lock) axle C2AZ 19580-B Hvpoid gear lubricant (rear axle)-5 gal. C9AZ 19554-A Perfect seal sealing compount-(12) 15 oz. container-So A. E 80 (temperature range-

aerosol can minus 250 and below) C9AZ 19554-6 Sealer (liquid butyl)-Black-for sealing butyr C2AZl9:JIlU-D HypoiQ gear lUbrIcant (rear axle)-l gal.-

installed windshield and backlite-1 pint can for high performance vehicles DUAL, Ujtjo'!-A I Kit-Ioctite minute bond adhesive 312-use0 on C2AZ 19580-F HVPoid gear lubricant (rear axle)-120 lb. keg on vehicles having sintered stainless steel (S.A.E.90)

rear view mirror bracket. -Consists of (1) ----_._.

50cc adhesive,(l) 6 oz. can accelerator ant:! C6AZ 19580-A Hypoid gear lubricant (rear axle)-5 gal. -not (1) instruction sheet used with limited slip (equa-Iock) axle

DOAZ 19554-B , Accelerator lor loctite minute bond adhesive C6AZ 19580-B Hypoid gear fubricant-5 gal.--used only 312-6 oz. aerosol spray can

with conventional axles -( For lifYht trucks with Dana axles applicable amount of

B6AZ 19558-B Protector pellets (cooling system) -carton of- C8AZ 19B546-A additive to be used with

C9AZ 195-58--X-12 pellets

-----complete fill)

fprotectorp-ellets (cooling system)- - - C6AZ 19580-D Hypoid gear lubricant-120 lb. keg-used only cartoll of 24 pellets with conventional axles -(For lif'ht trucks with

AB 19560-A Caulking cord-6-80 foot rolls- 3/ 16" diameter Dana axles applicable amount of C3AZl956u::A Body sealer (synthetIc resIn)~e C8AZ 19B546-A additive to be used with C3AZ 19562-A Sealer & filler (silicone rubber)-5 oz. tube-for complete fill)

---_._-------- ---------Vinyl tops, also body sealer-White C6AZ 19580-E Hvpoid gear lubricant-l e:al. -used only C3AZ 19562-B Sealer & fillerTsilicone rubber)-5 oz. tube-for with conventional axles -(for light truckS

Vinyl tops, also body sealer-Black with Dana axles applicable amount of C5AZ 19562-B Kit-Coach-joint sealer repair (1) 4 oz. can C8AZ 19B546-A additive to be used with

joint sealer (1) 1 oz. bottle with applicator complete fill) brush cap-adhesion primer (1) wooden C8TZ 19580-A -+-HYPOid gear-lubricanf(SAE9-6Fl gal.-~ spatula (for FI00/350.P350/400.E300 trucks with

DOAZ 19562-A Kit-windshield & backlite seal-butyl tape front driving axles & rear axles with Dana (172") -used when replacement of glass is power lock) necessary ant:! existing butyl tape is reliable C9AZ 19580-A Hypoid gear lubricant~for limited slip axle-

C9AZ 19577-A Refrigerant compressor oil-used with York (4) 1 at. -plastic container with spout or Tecumseh compressor-l pint Can ----~------. - --~- --- ---_._- - ---- ----_ .. _-

C6AZ 19562-C Kit-windshield & backlite seal-butyl tape (172" ) B3AZ 19581-A Speedometer cab[egrease-Ilb~ can ---.----~--- -- ---_. ----- r---. ---- ---- .. --- ----~--.--.--.-~----

C3AZ 19578-A steering gear lubricant (life time)-14 1/2 oz. C1AZ 19582-A Fluid (Automatic trans. & Power steering)-cartridge -1 quart can

B7A 19579-C Crankcase conditioner & rust inhibitor 160z.can C1AZ 19582-C Fluid\Automatic trans. & Power steering) *B7A 1\157\1-A I Carburetor & comDustTon chamber cleaner- -1 gallon can

16 oz. can RjB B7AZ 19579-A (12-69) C1AZ 19582-D Fluid (Automatic trans. & Power Steering) B7AZ 19579-A Carburetor & combustion chamber cleaner-

-~----.---

:5...5 gal..:d rUm - -- - . ---- --

(12)-24 oz. cans C6AZ 19579-B Carburetor & combusion chamber cleaner- B6A 19583-A Ru-Glyde -rUbber lubricant (for tubeless tire

(12) -20 oz. -aerosol cans C8AZl9583~P;-

servicing)-1 gal. can mil-Clyde - ruooer ruorIcanC(Torvacuum ~

C2AZ 19579-A Crankcase oil conditioner-16 oz. can attachment)-8 oz. can C2AZ 19579-B Crankcase oil conditioner 55 gal. drum

--_COAZ 19584-A_ Lubriplate (all purpose l_llbrican!Ll 3/4 oz. tube

C5AZ 19579-D Motor oil-5W=30(T q~.can) C5AZ 19579-P Motor oil- 5W -30 (1 gal. can) C4AZ 19584-A Grease (polyethylene) 8 oz. hi5e wIUi spour-

C5AZ 19579-E Motor oil-5W-30 (5 qt. ca!1)----------- C4AZ 19584-B Grease (polvethvlenel-16 oz. spray can C5AZ 19579-F Motor oil-5W-30 (55 gal. drum) B4A 19587-A Latch lubrrcant-cartano[TI=4oz. cans

---

FORD TRUCK PARTS PAINT SECTION XLI

PART NUMBER DESCRIPTION PART NUMBER DESCRIPTION

APPEARANCE & MAINTENANCE MATERIALS B8A 19589-A Lubricant (special purpose)-llb. C9AZ 19627--A T Tape-(iUtomotive masking)-3!4" wide-

60 yd. roll C1AZ 19590-B Lubricant(multi-purpose long life)- C-9AZ 19627-C-~e(iutomotive-masking)-2" wide-

14 1/2 oz. cartridge 60 yd. roll CIAZ 19590-C Lubricant(multi-purpose long life)-

120 lb. keg C8AZ 19628-A Tape (elec. insulating)-black (shop pkg. )-C1AZ 19590-D Lu_bricant (multi-purpose long life )-25 lb. pail 3/4" -44 ft. roll C1AZ 19590-E Lubricant (multi-purpose long llfe)-5 lb. pail 'C-8-AZ 19628-B Tape (elec. insulating)-black (shop pkg.)-C6AZ 19590-A Lubricant(steering linkage)-14 1/2 oz. 3/4" 20 ft. roll

cartridge C8AZ 19628-C Tape (elec. insulating)-black (display pkg. )-C6AZ 19590-B I Grease (bearll1g Iubncant)-4 oz. tube-used 1/2" -12 1/2 ft. roll

with T/E-pump assy. -exhaust air supply 'C8AZ 19628-D Tape (elec. insulating)-black (display pkg. )-C7AZ 19590-A- Lubricant(lower steering arm & spindle stop 3/4" -20 ft. roll

pads)-1 lb. can 'C8AZ 19628-E Tape (elec. insulating)-black (dispenser)-C7AZ 19590-B Grease-remote controllinkage-(tilt cab)- 3/4" -66 ft. roll

4 oz. tube

'C8AZ 19628-F Tape (eiec. insulating)-black (individual COTZ 19591-A Fluid (radiator shutter control)-1 gal. can metal can)-3/4" -66 ft. roll COTZ 19591-B Fl.~cljradiator Mutter COmrOI) -1 qt. can C8AZ 19628-G Tape (elec. insulating)-black (individual

skin pkg.) 3/4" -20 ft. roll C6AZ 19627-A Tape (vinylfoam)-1/8" x 7/8" -50 ft. roll-used C8AZ 19628-H Tape (e'iec. insulating) -black (individual - --- -- - t~ stlim weat!:,el'strip r_()~f rails and doors skin pkg.) 3/4" 66 ft. roll

USED TRUCK RECONDITIONING MATERIALS Color re-c-o-n~d';:;it';'io=-n-e--rC"--:Cmc-uCClfCt-:-p::CuC-:r:::p:C;o:C;s;c;e-:a;;-:u"'t:::Oo--­upholstery paint assortment (33)-1 quart cans of color reconditioner paint (3) -1 quart cans rubber sealer paint (1) color intermix card­(1) metal display rack

COAZ 19A536-D Engine shampoo (cleaner & degreaser)­~=~-=~~=-=-c~c-Ie::5..!g~:a=L drum COAZ 19A536-E Engine:::"-=s;:':ha'::m--p-o--o""(~c"le-a-n-e-r-&""d"e-g-r-e-a-s-er-)r_---

30 gaL drum Engine s'i-ha:::m:::.:.p-o-o....,(~C .. le-a-n-e-r-&:c-d .. e-g-r-e-a-s-er....,),...._---COAZ 19A536- F

____________ .5J5 gaL_ drum ________________ _

B9AA !9A537 -.:f\._~.tSh. Rub2.~r Mat-(1 Pkg. of 6) C7AZ 19A537-A Color reconditioner-rubber sealer paint--­

(for reconditioning rubber floor mats)-1 quart can - --------------------

C7AZ 19A542-M

COAZ19A547-~A "FlTler-\pcllyfillei'l-ooily repair Kit-{1}-1 quart container with (1) 1 1/4 ox. tube of COAZ 19I35J 2-A cream hardener attached to each quart

-C~-0-A-Z-1~9-A'~5~4~7-~B+~FiTIer\p61yrrn:er)-body repair-l gallon of COAB 19B542-A Cream (poly filler hardener)-l pkg. of 5-1 oz. plastic filler with (1) 41/2 oz. tube of cream -____ _,_ tub.e_s ___ ______ hardener attached COAZ 19B542-A Cream (poh'filler hard-·e-n--e--r~)--~l~p"k-g-.--0~f""'6"-""'1~1/-4-1 --------+---

oz. tube s snpplemental supply - used with -C-1-A~Z~1""'9""'6=2-=7 -_ A~--+-""T'-a-p-e-;(-p-:Cr-:-e-=-ss::-:u::-:r:-:e:-::Cse-=-n=-s=-i"'ilO:· z:-::e:::id') _'5'"';-C' w;;-;;;id'-;e~x'6;rO'-;v;;a;-;r:-;:;d~s COAZ 19A5J,7-A or B polyfiller body repair -used to recover arm rests, seats, floor material mats_,--~_. ________________ _

PART NUMBER DE SC R IPTION PART NUMBER QESCR IPTION

PLASTIC TINT - QUART CAN B9AA 19A539-A White

~B"9cA·~A··1~ 9~)A~!5~3~9'-~ Cf-~Bcr--o'-w-n---- ---.-+---.-------+-----

LEATHER and VINYL DYE - QUART CAN

------.------~~

-- ---_. - ----+--------

PART NUMBER D " SC R IPT 10 N P\RT NUMBER YFSCR IP r ION

PLASTIC DYE - QUART CAN ---------------- ~~AAl~A~41~E Gray B9AA 19A541-B Black B9AA 19A541-D Green

B9AA 19A541-F Blue

COAA19A541-A ye~ow ______ +-____________ ~---------------------~f--------------

FABRIC TINT - QUART CAN B9AA 19A542-C Gray

~----------~----------~B~9~A·A~1"9~A~5~4~0-~C Brown ---------------r-~-~~~----+-BnTIDVlKT .. 1~9A~!5~40~-Hr.-hT~ul~'q~u~oTis~e,-­

__ -+--=-:._~~.::.:...~j__:_.:::.::..:'-==_I __ ._ -----1--------1------+------

COLOR RECONDITIONER - AIR DRY AUTO UPHOLSTERY - QUART CAN C7AZllfA1>42=13 YelloW--- C7AZ19A542-H Red C7AZ 19A542-E Turquoise C7AZ 19A542-L Clear

C7AZ 19A542~D -MedIilm Copper C7AZ 19A542-K Silver

I I

'tlRD TRUCI( PARTI SECTION 10 1

INDEX INCLUDED IN THIS INDEX SECTION ARE THE FOLLOWING MAJOR GROUPS:

BRAKE SYSTEMS WHEE LS, HUBS & DRUMS SPARE WHEEL PARTS

SECTIONS 10 & 11 - WHEELS HUBS and DRUMS , GROUP PART NAM E GROUP PART NAME NUMBER NUMBER I

Actuator (free running hub ClutCh) 1098 Knob (lockout hub actuating) lA029 Adapter (rear axle shaH stud) 1142 Locknut assy. (front wheel bearing) 1197 Bearing assy. (free running hub inner coupling) 1092 Lock ring (free running hub inner coupling) 1080 Bearing ass'y. {rear wheel~-ball 1225 Nuf (aual rear <lisc wlieeI)-mner ~

BodY (free running hub clutch) 1093 Nut(dual rear disc wheel)-outer --rI34-5 Bolt {hub} 1107-8 Nut (hub bolt~ 1012 Bolt (hub}-L. H. tnread 1119 Nut {wheel} 1120-1 Bolt (hubl-R. H. thread 1118 "0" ring (free running hub knob) lA030 Bolt (spoke wheel rim clamp) 1151 on seal assy. (rear axle) TIIIT Bushing (lOCkout hUb) 1A023 Pin (free running hub drive) , 1094 (;ap (front hub grease) 1131 Pin (free running hub stop) 1095 -Cap (rear hub grease) 1248 Pin (lockout hul:) retaining cap) fA025 Cap (wheel hub) I 1130 Pin (rear wheel inner bearing spacer) 1A012 Clamp (spOke wneel rim) 1042-3 Plate & pin (lockout hub retaining) lA020 Cone and roller ass5< (front wheeTbearmgy-~- --l422i~~ Retainer (front wheel bearing lock) 1198 Cone and roller ass'y. (front wneel inner bearing) 1201 Retainer (front wneel grease) 1190 Cone and roller ass y. (fronf wneeT outer bearing) 1216 Retainer (rear wheel bearing)-inner 1180 Cone & roller ass y. (rear wneef and diff. bearing) 1244 Retainer ,rear wheel grease) TI'75" Cone and roller ass y. (rear wneef outer bearing) 1240- Retainer (rear wheel grease) -outer I 1246 Control assy. (free running hub) 1089 Rim ass'y. (wneel} I 1020 Coupling (free running hUb) 1090-1 Ring & cam body assy. (lockout hub) 11AO~~ Cover (brake cylinder) :lU55 Ring assy. (wheel trim) I 1210 Cup (front wneel bearing) 11M2 Ring (free running hub clutch)

1

1101

I 1243 Ring (wheel rim lock) 1021 4222

11177 Cup (front wheel outer bearing) 12f'l Seal ass'y. {rear wheel bearing oil)-inner Cup (rear wheel or differential bearing) 1243 Seal (front nub grease) . 11!)S Cup (wheel bearing) 1239 Seal (rear hub e:rease) 11249 Drum (front Drake) I

1125 Shim (free running hub clutch) 1070 Drum (rear brake l 1126 Sleeve & ring assy. (lockout hub) 1A02fi F'lange (wlieel rIm) 1099 Slinger (rear !iu!) oil)

11165

Gasket (front air brake slinger) 1152 Spacer (disc wheel hub) lA014 liasket (front brake grease ~ 1193 spacer (front hub) 1199 Gasket (front wneelnub and grease cap) 1153 Spacer (front hub grease retainer) 11212 Gasket (lOCkout hUb housmg) 1AU21 Spacer (front nub to spindle) IHl4 Gasket (rear axle wiper)

1

1187 Spacer ,front wheel inner bearing) 1213 Gasket (rear hub) Spacer ,rear spOke wneel rim) 1044 . 1183 Gasket (rear Wheel bearing retainer or rear i 1001 Spacer (rear wheel inner bearing) lAOll

axle shaft) Spring (lockout hub) 11A024 Gear (front axle shaft drive) 1245 Washer (front hub grease seal retainer) ; IHl1

Washer (front hub outer bearing) ! 1195 Housmg assy. (lOCkout hub)

I ttt:c Washer (.rear wheel nearing nut lock) • n2~ Hub and brake drum ass'y. (front) Washer (rear w!ieel grease retainer) i 1180 Hub ass'y. (front}·-· 11247 Hub assy. (front spokewneel) 1104

Was!ier-thrust (free runnL'lg hub) 109 1088 Hun assy. (rear) I 1109 Weiglit (wlleeI Balance) 11040 Kit (full wheel cover) I 1130 Wheel ~ flange i 1007 Kit (front hub grease seaT repair) I 1196 WlleeI assy. 1015 Kit (seal & lock rine:-free runnine: hub) ! 1097 ~iper ass'y. frear axle shaftl ___ . __ .. ______ .11174 __

SECTION 14 SPARE WHEEL CARRIERS -Bar (spare wheel carrier stop) 1496 Kit (side mounted spare wheel lock) 1386 l!Qltjspare wheel carrier hinge) 1471 LocKa56Y :1siae -mounteaspareWliee 1) ':wfth-keys .. 13"80-----Bolt (spare wheel carrier support) 1408 NiiTTspareWlieeICarrieroOIf)-- ------------

H62 "BOlt(spare w eel mounting 1448 Nut (sparewneeI"carrier limge-001l:j . 1476 Bracket (frame to spare wheel carrier) 1453 Plate (spare wheel retaining) 1424 Bracket (spare wheel carrier locating) 1445 Reinforcement (spare whee; carrier) 1407 Bracket (spare wheel carrier support to cross sill) 1415 Reinforcement( spare wheel carrier to floor side sill) 1413 CarrIer (spare w eel) 1433 Refamer (side Ill_ouIiteQspare whee!L 1474 Channel (s2are wheel carrierT 1443-44 Stud (spare wheel carrier) 1458 Clamp (spare wheel) ------

1446 SUP.P~t ass_'!~lspare wheel carrier) l4ITO ExtenSion (tire valve) 1705 !Upport (sPat'e wne~l,:,c?Iilersl:opDarr-----_0

H97 -------~.--- -.-~-.--f---.--

2 SECTION 10 FtJRD TRUCI{ 'ARTS

INDEX SECTIONS 20,21,22, 23, 24, 26 and 28 _ BRAKE SYSTEM

PART NAME GROUP NUMBER

Actuator assy. (front air brake) 2B002 Actuator (rear aIr braK:.!. 2tlUU3 Adapter assy. (brake vacu-u-n-l 7b-o-o-stC-e-r-p-u-s-oh-r-od<).------+-2"B"0'"1.--4.--Adapter(air compressor mounting) 2A880 Adapter (brake booster air control valve bOdy) 2;$26 Adjuster ass y. (front air brake) 2308-9 Adjuster ass'y. (rear air brake) 2314-5 Arm ass y. (aIr braKe peaal) -~-

Arm assy. (parking brake-:c=::::a:-'bl~e-lc-· d=1-e~r)c--------h2C-;AC:6~7C=3c---

Baffle (brake grease) 2240 Baffle (vacuum booster air cleaner) 2A(J85 Band and hmng assy. (parking brake) 2648 Bar {parking br::a-"ke~_a:::nc::ch:.:o::.-r,-,')~ _________ -+1-=:2~6:2",,1~_ Base assy. (air brake pedal) 2A239 Bearmg assy. {airbrakepeCla.1-cross shaIt)--- 2A2~T---Bearing assy. (vacuum pump rotor shaft) 2B039 Bearing (air compressor belt idler pulley) 2873 Bellcrank (parking brake,,) _______________ -+-,,2:,.A,.6;.:6:...:3'-_ Belt (air compressory-- 8620 Blade (vacuum pump rotor) 2A560 BOdy ass'y. (brake booster) 2366 Bodyass'y. (brake booster controD 2327 Bodyassty. (brake vacuum boosterr"fr-o,.-n't------jI-~2~3~2;,;9~--BOdy (bOoster control vaIve) I 2419

l3OUY(OOoster hydraulic cylinder) 2425 Bolt (brake Inlet. outlet &. clutch fitting) 2U77 Bolt\front brake carrier plate to spindle) ~g~~

1JOff (master cylinder link rod to pedal) 2462 Bolt (master cyI.outIetfittingto master cyHndeiT 2276 Bolt (Parking brake banct ancnor chp adJusting) 2616 Bolt (parking brake drum to universal joint flange) 2624 BolC(parking brake lever sector to shifter housing) 2799 Bolt rear brake carrier Plate) ~~!~

Bolt (rear brake cylinder connectioll=--=-to~c-,,-y-=-li:::n-=-d:.:e_r,---) _+.2;;-;2~7;-:6;;-;;-_ Bolt (vacuum DumD mounting) 2B106 Booster assy. (brake) 2005

-.!B~o;!!o,!.!tcJ(c!'ai':!or~b'.!cr~ak~eJ:p~e",d~a:=,l~to~f~o~ot~c~o:.:nt",r-"o~1--,v-"a~lv.:.:e::..l)'-____ 'h'2~A:;2.;.4:;:.2 __ Boot (brake air chamber) 2B021 Bootlbrake & clutch master cylinder_)'--____ -+-7;2!1i7;i80;-".--Boot (brake cylinder) 2206-7 Boot (Darking brake lever) 2A713 Boot (parking brake valve cable) 2A769

Brace (air compressor) 2888 Brace (parking brake lever support) 2A 702 Bracket assy.(park1ng brake cable support) 2A669 Bracket assy. (parking brake rear cross shaft) 2651 Bracket assv. (rear brake shoe anchor) 2A497 -8 Bracket (air brake pedaI arm bum.~p~e~r!.-) _______ -I-.:;;24;'4;;8 __ Bracket (air brake pedal to floor) 2467 Bracket (air brake Quick release valve mounting)- 2A268 tractor eQuipment

PART NAME

Bracket (brake booster mounting) Bracket (brake check valve) Bracket (brake master cylinder) Bracket (brake reservoir mounting) Bracket (brake vacuum pump) Bracket (carb. air cleaner to compressor hose) 'Bracket (front brake air Chamber) Bracket (front brake hose) Bracket (parking brake)

Bracket (parking brake air control valve) Bracket (parking brake cable support) Bracket (parking brake control mounting) Bracket (Darking brake support) Bracket (parking brake to transmission case) Bracket (parking brake tube connector) Bracket (parking Cable)-rear Bracket (parking equalizer)

Bracket (rear air brake relay valve) Bracket (rear brake hose) Bracket (rear wheel parking brake cable to

instrument panel)

GROUP NUMBER

2031-2 2A772 2280 2A206 2A452 2A888 2306 2082 2A687 2795 2A730 2649 2836 2A696 2654 2A738 2530-1 2631

.'2TIO-I-2A491 2073 2A474

Bracket (tractor brake tube support)-tractor 2A314 trailer eQuipment

Bracket (trailer air hose returni.:cng<e....::s"'p::.r ___ in~g~} ___ -----1--'2"'9';;'5"'9;;-__ Bracket (trailer bracket air-'h:'.'0~s~e'--s~u~po,!p-"0"r~t)!..-.-_---;-;-_ch2,,5c,;3~3~ __ Bracket (trailer brake air hose connector mounting) 2954 Bracket (trailer brake air hose support) 2953 Bracket (trai!eJ::_b!a.ke emergency air supply valv~ 2948

Bumper (pedal to floor board~)_----:-c--__ , ___ ---+--,7:::-5~8:::3:-;:--_ BumDer (vacuum booster Dush rod) 2A366 BUShing (brake & clutch mas~te~r-'-"'c"'-oYlh-i::-nd'eC-:r,·)----n2i'14~774'-"---Bushing (brake booster) 2372 Bushmg (brake shoe anchor p~ 2028

2B087 Bushing (brake vacuum booster plunger guide) 2A386 Bushing (front air brake camshaft) 2290 Bushing (master cylinder push rod) 2A309 Bushing (operating lever) 7526 BushIng (parking brake band camshaft) 2'114

-Bushing (parking brake rear cros,-,s~sh~af~tL) ____ +2~8~4~6~--Bushing (pedal) 2461

Bushing (pedal bracket) Bushing (rear air brake camShaITOr carrier plate) Bushing (vacuum booster push rod) Bushing (vacuum pump rotor shaft) Button (parking brake lever) Buzzer (low air pressure)

2471 7526

12470 12237 2385

2791 2573

Bracket (air brake quick release valve to frame 2A279 Cable & conduit (parking brake) 2853 cross member) Cable assy. (parking brake air control valve) 2A768

Bracket (air brake tube suppo<:.rt';()~_~~~ ______ +;i2",A",2",7c::5__ Cable assy. (parking brake) -rear 2A635 Bracket (air compressor belt idler adj. pulley) 2877 Cam (parking brake band) 2632 Bracket (air compressor to cC::Y)'Jl~in~d~e~r~bl~o:"oc",k~) ___ --+-ii2'ii8'if8'f2__ Camshaft & lever assy. (parking brake) 2A71O Bracket (air compressor to manifold) ___ , _______ 1_2~8T8~6=-- Camshaft (l'ront aIr bra:kej----------- 2230-1 Bracket (air compressor tube) zA886 ~amshaft (rear air brake) 2316-7 ~B~r~a~c~k~e~t~(b~r~a~k~e~ai~r~ch~a~m~b~e~r;s~u~p~p~o;rtT.)~~~~ __ ~2p.lA~'4~9~9~- ~C~a~p~(~a~i~r;c~o~m~p~r~e~s~s~o~rdP~u~l~le~y~)~Tr.~~TITA-r.---_l~2~8n94rir--Bracket (brake air reservoir mounting)-upper 2320 -C-ap (brake &. clutcn master cylinder filler) 2162 Bracket (brake and ClutcI1J)_~a!L __________ +-=-=-246,--,-7__ Cap (vacuum pump opemng) 2B042

F'RD TRUC/( 'ARTS SECTION 10 3

INDEX SECTIONS 20, 21, 22, 23, 24,26 and 28 - BRAKE SYSTEM - continued

PART NAM E GROUP PART NAME GROUP NUMBER NUMBER

Chamber assy. (front brake)-air 2025 Elbow (brake vaccum booster tube) 2420 Chamber assy. (rear brake)-air 2225 Elbow (brake vacuum booster control valve body) 2328 Clamp & support (brake booster vacuum tank) 2084 Elbow (vacuum pump intake tube) 415U47 Clamp ass'y. (brake vacuum booster breather hoseL 2342 End plate assy. (brake-boosterT 2329 Clamp assy. (power steering return line) 2344 Equalizer {parking brake}-rear 2768 Clamp assy. _(~ransE1atic trans. oil overflow hose) 2344 Equalizer (parking cable) 2A602 Clamp\l:li'ffi vacuum bOOSfernose)~-- - -------- !!2!!7 Extension (parking brake cable support) 2A742

18572 Clamp (front brake air chamber) 2A593 Field (compressor)-with pilot bushing

12987

Clamp or stud (brake vacuum booster body) 2350 Flller (Drake master cyhnuer pISton) 1 2146 Clamp (rear DraKe au cfiamDer) 2A470 Filter (brake vacuum booster air cleaner) 2A346 Cleaner ass'y. (brake vacuum booster air) 2363 Fitting (air compressor discharge) 2A877 Clevis (front brake air chamber operating rod 2099 Fitting (brake ~ clutch master cylinder outlet) 2076 Clevis (parking brake bellcrank) 2A712 Fitting (vacuum pump oil cheCK valve) I 2B046 Clevis (parking brake cable adjusting) 2854 Flange (vacuum pump intaKe tuoe) : 213048 Clevis (parking brake lever adjusting) 2484 Clevis (parking brake lever to cross shaft rod) 2857 Gasket {air compressor mounting surface cover) 2945

Clevis (parking brake rod) 2854 vaSKet (aIr compressor to mounting aaaptor) 4!!litl Clip {brake cable) 2!!14 Gasket (booster push rod seal retainer) I 2B075 Clip {brake hose & pipe) 2814 i Clip (brake pedal spring) 2A189 Gasket (brake air chamber mounting) I 2B036 Clip (brake pipe) 2244 Gasket (brake ~ clutch systemT I 2151-4 Clip (brake system) 2279 Gasket (brake booster) I 2437 Clip (pipe to frame) 14577 -Gasket (brake booster hydraulic cylinder) 2493 Clip (rear air brak,"- sh()~ hold downT :m02ti Gasket (brake booster vac. control valve body cover) 2479

Gasket (brake master cylinder filler cap) 2167 Co!larJ~rakev~cuum b~oster push rodl 2440 GasKet (Drake master cylmuer reservoir) 2142 ConneCTIOrl{froiifbrake cyrrrure-I'Tnletr- ------~ - --W-su---- Gasket {brake system) 2149 Connect~Qaptor -assy.-Tcompressor-air-intakeT ----z:ror-- Gasket (brake vacuum booster) , 2373 Connector ass y. (parking brake lever To cam) 2tltlJ Gasket(brake vac. oooster cneck valve oody) i 244'1 Connector (air supply to stop light switch) 2A292 Gasket (brake vacuum pump mounting) 2A453 Connector (brake pipe) -front 2075 Gasket (rear air br~~shoe~ltl~~r gu~~_ 2B032

~------~-

Connector (brake pipe to rear axle housing) 2074 Coupling assy. (brake hose) 2A384 Gasket (vacuum booster control vaIve cap assy. 2::ltlU Coupling (brake vacuum pump drIve) 2A4t>t> to poppet valve body)

Gasket (vacuum pump cover) 2A572 Cover assy. (front braKe au Chamber cyIinaer) 2Atl\!4 Gasket (vacuum pump intake elbow) 2B050 Cover assy. [rear brake au chamber cyllnaer) 2A469 Gasket (vacuum pump 011 checKvalve) 2A~

Cover assv. (vacuum pump) -front 2A557 Gasket (vacuum pump intake tube) : 2B049 Cover assy. (vacuum pump)-rear :lA558

I Cover (brake adjusting hole)-steel & rubber 2092 Gauge assy. ( air pressure) 2557 cup (brake & clutch cylin<1er) 22UI-J Gauge assy. (vacuum) 2A036 Cup (DraKe Ri clutcli master cy tinder prlmary) 217;:1 Governor assv. (air compressor) 2885 Cover (brakebooster vacuum control valve body) 2326 Grommet (parking brake lever to floor board) 2652

Cup (brake booster vacuum control valve pistoUL 2J99 Guard (valve body) 2180 ~~~de (air brake shoe a~~~tor r>!tlnger) 2B005 Cover (brake cylinder) 2055 -- ----- _ .. - j--------

Cup or washer (brake shoe hold down sprIng) 2Uoti Cup (vacuum booster hydraulic cylinder piston) 2408 Handle (parking brake) 2760

Cylinder ass y. (brake) 2061-2 Hose assy. (air brake foot control valve to 2353

2261-2 manifold fitting)

Cylinder ass y. --<-brake master) 2140 Hose assy. (air brake foot control valve to Quick 25tl7

CyTinCier assy.\IToritbi'aKeaIrcliariiber)----- ----~U-

release valve) Hose assy. (air compressor governor to

I 2989

Cylinder (brake booster control val vel 2417 Cylinder (brake booster hydraulicT 2425

governor tube) 2903 Hose ass'y. (air compressor to governor)

Cylinder (rear brake air chamber) 2A463 Hose-a-ssy:\Orake) ---- --- --- - - --- . - -zo'78-

Hose assy. (brake tube) 2A245 Detent (air brake shoe actuator adjusting) 2B008 Hose ass y. (compressor oil inlet & outlet) 2922 Detent (rear brake air chamber adjusting screw) 2B029 Rose ass y. (manifOla to vacuum-lube)-flexible 2353 Diaphragm (brake air chamber) 2325 Hose assy. (p_arkirlg b~a~~_emer!S€ncy_ air suI1l}~ __ 2A775 Diaphragm (brake boost~r vac. control valve) 2324 Hose assy -:-\rear air brake J-TIexible 2A2liO Diaphragm (brak~ vacllum booster cylinder) 2394 Hose assy. (rear brake) 2282

Drapliragm (vacuum boOSterooayT -----~ - ~--

~4---

Hose assy. (trailerpl'3:"-e airl ___ ~ ______ ~ ___ 2A138 Diaphragm (vacuum booster control valve) 2391

---~~

Disc (brake vacuum b::>oster control valveT 2308 Hose (air compressor tube)-water 2-2917 Drum (parking brake) 2614 Hose (brake booster reservoir tank gauge) 2A037 Dust shield (rear brake carrier) 2214-5 Hose (brake check valve to intake manifold) 2A046

4 SECTION 10 FtJRD TRUC/( 'ARTS

INDEX SECTIONS 20, 21, 22, 23, 24, 26 and 28 - 8RAKE SYSTEM - continued

PART NAM E GROUP NUMBER

Hose (brake vacuum booster) 233G P' Hose (brake vacuum booster tube) front 2-2334 m (rear air brake shoe retracting spring) 2341 Hose (brake vacuum booster tube) rear 2-2336 Pin (rear air brake snoe_to cam roller} ! 2045

--;HHn'os~e~(c~a;;::r;;jb~u;-;r;;;e~to;;:r~aiir~ci.le;;:;a:::n~e::r:::t~o?-:-co~m;;p~r-=-e-=-ss::-o:-r--,-------l--2~9;;7~4~'--- Pin (rear brake shoe anchor) 2333 Hose (hydraulic brake lines connector) 2270 Pin (rear brake shoe retracnng spnng) llAo'!7 Hose (manifold to brake vac. booster check valve) 2-2352 Pin (vacuum pump drive flange) 12A535 Housmg ass'y. (front air brake camshaft) 2304 Pipe assy. (check valve to brake vacuum booster)-!owerI23ti2 Housing assy. (rear brake air chamber cylinaer) 2B034 ~;!l~as~y.ic:h~c:J{valvet()~a\{!lllacuum booster)-upperI234\! Housing (rear brake air chamber cylinder) 2BO!r5 PIpe (Drake DoosTer) -- --:!352- ---Housing (vacuum pump) '--~--"':--'-----+-""""ll!j"";U'!!"::;-'4- i>fsToU-assy.(D-raKelioost:ei-!)oifYT - ------ - - "'"2395"--

i>fSfOiiassy;\OrakeboosteifiydrauliccyTindeiT ---~---

Kit (brake booster major repair) 2309 Piston (brake & clutch cylinder) 2196-7 Kit (brake bOoster minor repair) 2307 PIston (brake & clutch master cylinder) 21ti\! Kit (brake booster piston packing) 2337 Piston (brake booster control valve) 2396 Kit (brake cylinder repair) -----------+"2<12..-8------ Piston (brake vacuum booster body) 123\14

2221-2 Piston (brake vac. booster hydraulic cylinder) 2446 lKi:mct!(lib"r"ak""e;;--;;m~as=tC;;e:;;r-;c"y"l.,-;m;;-;dr.ec:;r;--&o:-Ib::-:o"'o"'t..-J------ --+-lff2147-10;....:'----- Piston (rear brake air chamber) 2B027 -Kit (brake master cylinder repair) 2004 2A464 Kit (brake shoe & lining) 2001 Kit (brake shoe hold down) 2A094 Kit (brake shoe lining) 2007 Kit (brake vacuum booster poppet valve repair) 2433 Kit (brake vacuum pump) 2A473 Kit (camshaft replacement) 2A 710 Kit (front air brake adjuster bolt repair) 2090 Kit (rear air brake adjuster retaining washer) 213() Kit (rear shoe & lining) 2200 Kit (rear wheel parking brake repair) 2A753 Kit (tube and hose compressor to engine repair) 2912 Knob (parking brake air control valve) 2A736

Plate assy. (front brake carrier) I 2u12-.;s-Plate assy. (rear brake carrier)"----------l,......-n 2:2 .. 1:;.1~-2;.....-Plate assy. (trailer braKe alr nose aaapTer cover) 2A:l40 Plate assy. (vacuum pump rotor seal) 2A537 Plate (booster mounting bracket) 2A476 Plate (brake & clutch master cylinder piston stop) 2188 Plate (brake shoe anchor pin) i 2U2H Plate (brake vacuum booster bodv piston)-front 2429 Plate (brake vacuum booster diaphragm) 2394" -i'pil:=ati:e:-K-:(b:r=a:'i:k==e--v=a=-c=--u::.:u:::m=--;-b=--o:...:o:..:s;..te::.:r:......::p~is=!t=-O=-n),.::::."=~-----t-;.2 3~ Plate (parking brake support) 2A636 Plate (vacuum pump oil seal)-front 12A554

Lever assy. (parking brake) 2780-1 Plate (vacuum pump oil Seal)-rear i 2A555

Lever (air brake pedal cross shaft) 2496-7 Lever (parking brake camshaft control) 2816 Lever (parkmg brake operatmg) 2A637-8 Lever \parKlngora:Ke rear cross shaIt)-inner 2816

-Lever (parlUng brake rear cross shaft) -outer 2772 Lever (parking equalizer) 2Ati05

Plug (booster control valve) 2A088 Plug (booster hydraulic cylinder end) 2369 Plug (brake vacuum booster oil) 2A587 Plug (vacuum pump opening) 1 2!j041 Plunger (air brake shoe actuator) 2B004

Lining (brake shoe) 2021-22 Lining (parking brakeT 2620 Lining (rear brake shoe) 2284-5

Pulley assy. (parking brake cable) 2804 Pulley (air compressorr 2884

)?ump (brake vacuum) 2A451

Link (parking brake connecting) 2861 Link(parking brake operating lever to primary shoe 2A642 ReservOlr (brake master cylinder) I 2141

.;L~i~nk;'?(frp~a~r~kT,ing~~bira;ikGO;e,.:;;sn.~oie::;r~e;;tr;;;a~c~tiing~~S~P~rl~' n~g~)'L~::5~';2;;7';:15~-- Retainer (booster air cleaner) 2A346 Link (parking brake to transmission) 2630 Retainer (brake air boomer body pIston return spring) 2394

Retainer brake booster bOdy plSton packing) i 2394 Nut (air brake Chamber OCK) lltlUUl Retainer .brake booster puSh rod seal) Ill:lIH Nut \oraKe adjusting screw) 204"7 Retainer brake booster push rod vac. seal sprmg) 2431 Nut (brake air booster body piston packing retainer 2033 Hetainer lDrake booster vacuum control valve body 1

2415

Nut (brake booster control tube) 2133 cover) Nut (brake pipeT 2133 Retainer (brake-booster vacuum control valve Nut (parking brake equalizer lever) 2091 piston) _"e" washer _Nu_t:---,---\r_ear_·_ Dlrak_le_ad...,,:J,---u--,-s-,--tll::.:n5'.g..:..:..:: bO=lt:l.....) _______ -l~2~2~2~3 __ Retamer (Drake vacuum Dooster corlfr61 vaTve

piston diaphragm)

-'-'0' ring (booster contrOl valve p'ston stop)

Pad (brake & clutch pedal)-rubber Pad (pectal plate) PaWl \parKing brake lever) Pedal (air brake) Pedal (hydraulicbraker Pin (brake pedal clevisr Pln (brake shoe anchor) }>in (brake shoe hOld(fown spring) Pin (parking brake handle locking) Pin (parking brake lever)

12378

2454 ! ll407 12786 2454 2455 2489 2027

2819 2859

Retainer (brake vacuum booster control valve piston ring)

Retainer (brake vacuum booster fulcrum lever) Retamer\Drakevac. booster hyd. cyl. checkValvej Retainer (brake vac. booster piston return spring) Retainer (front air brake shoe roller to cam)

Retainer (parking brake lever boot)

Retainer (parking brake lever grommet) Retainer (parking brake opel,"ating lever pin) Retainer (parking braKe valve cable boot)

2378

1 2429

2423

2A370 : 2459 2431 2046

1 2405 2A714 2765 2106 2A77U

FORD TRUC/( 'ARTS

INDEX

SECTION 10 5

SECTIONS 20, 21, 22, 23, 24, 26 and 28 - BRAKE SYSTEM - continued

PART NAME GROUP PART NAM E GROUP NUMBER NUMBER

Retainer (rear air brake applicator spring) 2A467 :Shaft & seal (brake vac. booster center control valve 2305 Retainer (rear air brake camshaft bracket seal) 2A312 Shaft (air compressor belt idler pulley) 2876 Retainer (rear air brake shoe roller) 2356 Shaft (brake pedal) 2478 Retainer (rear brake air~hamber diaphragm 2A468 Shaft (pedal~ 7506

return spring) Retamer (vac. booster hydraulic cyl. piston spring) 2423 Shield (air compressor governor heat) 2A878

Shield (parking brake drum) 2A703-4 Ring (booster body to control valve transfer bushing) 2-2421 Shoe and lining assy. (brake) 2018-9 Ring (brake booster end plate) 2373 Shoe and lining assv.(rear brake) 2218 Ring (brake booster ~dra~c piston stoP) 24U9 Ring(brake vacuum booster bellows wear) 2B074 Sleeve (brake vacuum booster) 2B014 Ring (6rake vacuum booster tube to body) :l4:l8 Sleeve (parking brake ca61el 2A776 RlngJvacuum pump sealing) 2A551 Sleeve (vacuum pump rotor snalt bearIng) ~l::l04U

~inger {front hub oilL 2241 Rod assv. (brake actuating arm to lever) 2A221 Roa ass'y. \brake master cylinder push) 2143 Snap ring (brake air booster push rod) 2332 Rod assv. (brake treadle cross shaft lever) 2A220 ;;nap rmg (brake & clu!~h master cylinder piston) ~174 Rod assv. (parking brake control) 2824 Rod assv. (parking brake lever to cam) 2A668 SocKet (6rake aaJusHng screw) :lO413 Roa assy. (parking brake rear cross Shalt lever) :lllti4

Spacer (air brake camshaft adjuster) 2138 Rod U:>rakel

-- ------_.

24G2 Spacer (air compressor mounting bracket) 2887 Rod (brake vacuum booster push) 2377 Spacer (brake manifold air fitting) 2A308 Rod (front brake air chamber piston) 2A5lJ1 Spacer (brake vacuum booster air cleaner mounting) 2A534 Rod (parking brake band adjusting) 2642 Spacer (parking brake adjus~ng rod release spring) 2637 Rod(!>arking brake equalizer) 2628 Spacer (parking brake lever or shaft) 2849 Rod (parking brake lever to cam)-universa1 2826 ;;pacer ~rear braKe cylinder cup) 2227 Roa (parking brake lever to rear cross shaft lever) 2853 Spacer (vacuum booster control valve spring to disc) 2390 Rod (parking brake rod replacement chart) 2853 Rod (rear brake air chamber piston) 2A465 Spider (re~ ai~ake_car~~E L_"" __

" ""------~"211-3

Rod (rear brake cylinder to brake Shoe push) 2129 Sprmg ~ ret. (6rake ~ dutch master cyl. piston) :l14b

l:tOl1er (aJT brake peaal) 2474 Sprin!1: (air brake actuating pedal arm) -retracting 2A241 Roller (rear air brake shoe anclior pin) 2359 Spring (booster vacuum control valv~_ ~~-

~otor assy. (vacuum pump) ~A7titi Sprmg (brake aa]usting screw) 2049 Spring (brake air chamber diaphragm return) 2321_

Screw (air 6raKe shoe actuator gUlae retaImng) :<l:IUU'( Spring (brake booster) 2361 Screw (bleeder) 2208 2418 Screw (brake adjusting)--- 2041 Spring (brake booster control valve diaphragm 2392

2046 return) 22U4-0 ~cr~\lI J~acuuI11~~mp rE!ar cove_I1_ 2l::lU54 __ Spring (brake cylinder piston return)

-- -"--- - Sprmg (5raKe shoe hola down)

1

2068 Seal assy. (air brake shoe actuator) 2B009 Spring (6rake shoe retainer) 2125

2035-6 Seal assv. (brake pedal rod) 2A258 Spring (brake shoe retracting) Seal assy. (rear air brake spider camshaft) 2B038 2296-7 Seal assy. (vacuum pump rotor shaft) 2A553 Spring (brake vacuum booster check valve) ~43\J_

Spring (brake vacuum booster pUSh roa seal retamer) :<375 Seal (airJ)rake camshaft bracket) 2330 Spring (diaphragm return) 2A157 Seal (booster push rod bushing) 2373 Seal (booster vacuum control valve piston) 2399 Spring (parking brake adiustin~ 274\J

Seal (brake and clutch pedal) 2476 Spring (parking brake adjusting rod release) <ltiiS4

Seal (brake booll{er_vacuum PUSh_ rod) ~3134 Spring (parking brake band support) 264~

Seal(brake vacuum booster check valve) .. - - 2B073 Spring (parking Drake compression) 2635

~eal_ (brake vac" booster front bOdy to end plate bOlt :l31l7 Spring (parking brake lever) I <l'{\JiS

Seal (brake vacuum ;lUmp intake tube elbow to flange 2A457 Spring (parking brake lever pawl) 2788 Seal (brake vacuum pump oil inlet) I 2A454 Spring (parking brake lever return) , 2A651

I 2A713 Spring (parking link) 2A601

Seal (parking brake cable) Seal (rear air brake camshaft bracket) 2A311 ::;prmg (pedal retracting) ~4'I2 Seal (rear brake all' cnamner) ~1:jU:<~ Spring (rear air brake applicator) 2A466

Spring (trailer brake air hose retaining) 2955 Seat (front air brake shoe to cam) 2023 Spring (vacuum pump rotor seal plate) 2A552 Sector (parking brake lever) 2790

232:l_ -- ----~- ---- ------ 2795-6 ; Stem ass'y,Jbrake booster air can, valve diaphragm)

-------- -----. ------

-

6 SECTION 10 FORD TRUCK PARTS

INDEX SECTIONS 20. 21. 22. 23. 24.26 and 28 - BRAKE SYSTEM - continued

PART NAME I GROUP PART NAME GROUP

NUMBER NUMBER

Stop(brake booster slave cylinder piston) 2A265 Tube (air brake relay valve to tee) 2269 Stop (brake vacuum booster control valve piston) 2312 Tube (air brake relay valve to tee) 2A027

Tube (rur brake release valve toIIffingj 2050 Strap assy. (brake air reservoir) 2A271 Tube lair brake stop light switch) 2A286 Strap (front brake slioe anchor pin) 2028 Tube (air brake tee to Iront hose connector )-L. H. 2915

Tube (air brake tee to front hose connector r-R.H. 2914 Stud (brake carrier plate to air Chamber) 2043 Stud (brake vacuum booster bodyT ~;:st>u Tube (air compressor governor to dash tee) 2A294 Stud Uiarking brake linle) 2837 TuDe (rur compressor to reservoir)-at engme ~91}

;:;tua (rear rur Drake dust shield spacer) 2224 Tube (air compressor to reservOlr)-mtermediate ;w17 Stud (vacuum pump cover) 2B051 TUDe (aIr compressor to union) 2917

TuDe (aIr compressor to water pumpT 2894 Support assy. (tractor brake air hose) 2A313 Support (compressor bracket) 29U2 Tube (air hand control valve to two way check valve)- 2-2498

2907 tractor equipment Support (compressor mounting bracket) 2A881

---~---~-- - ------ -- - - -

Support (parking brake cable) 2A664 Tube lair reservoir connecting) 2571 Support (parking brake lever) 2A707 2A135 Support (parking brake lever sector) 2797 2918 Support (Tractor Trailer brake air hose bracket) 2A410 Tube (air reservoir to booster) -tank end 2589 Switch (low air pressure) 2A574 TUDe (air reservoir to brake booster) 2-2907

Tube (air reservoir to relay valve) 2A026 Tank assy. (air reservoir) 2063 Tube (air reservoir to tee) 2A146 Tune ass'y. (air compressor oil inlet) 2908 Tube (rur reserVOIr to umon) 2904

Tube assy. (air compressor to governor) 2903 Tube ass'y. (brake & fuellineT-steel 2265 Tube (brake air booster to dash tee) 2570 Tube assy. (brake booster inlefJ-2nd section 2A031 Tube (brake air chamber connecting) 2A495-6

Tub" assv. Ibrake tee to rear axle hose) 2A284 Tube (brake air control valve to limit & quick 2A216 Tube assy. (brake vacuum bOoster) 242U release valve)-lower Tube assy. (brake vacuum booster outlet) 2234 Tube (brake air control valve to limit & quick 2A215 Tube assy. (forward rear right wheel brake) 2A217 release valve)-upper Tube assy. (front brake cylinder connection) 2A335 Tube (brake air foot control valve to dash tee) 2A276 Tube assy. (front brake hose to cyUnaer) 2A361-2 Tube Ibrake air foot control valve to front tee) 2A274 Tube assv. (frt. brake hose to tee) 2A156 Tube (brake air foot control valve to manifold fitting)2A285 Tube assy. (intake manifold to check valve) 2269 Tube (brake air foot control valve to two-way check 2A273 Tube assy. (left hand brake)-forwara rear axle ~A~Hj valve)-tractor trailer equipment Tune assy. (master cyl. to front brake connector) 2-2264 Tube assy. (master cylinder to rear brake hose) 2A272 Tube (brake air hand control valve exhaust) 2-2496 Tube assy. (master cylinder to rear brake tuDe 2-2271 Tube (brake air hand control valve exhaust)- 2A121

connector) tractor trailer Tube assy. (rear brake cylinder connection) ~2!l~ Tube (brake air hand control valve to foot control 2A307 Tube assy. (tee to forward rear axTe Drake hose) ~-~~;:Sll valve) -tractor trailer equipment

2A283 Tube (brake air hand control valve to manifold}- 2-2499 Tube ass'y. (tee to rear brake hose) 2-2277 tractor equipment TuDe ass'y. (tee to rear rear axle brake hose) 2-2240 Tube (brake air hand control valve to manifold)- 2A050

Tube assy. (vacuum gauge) 2A253 tractor tailer equipment Tube assy. (vacuum pump to brake ClieCK valve) 2A41:$\) Tube (brake air hand control valve to tee) 2-204z

Tube (brake air hand control valve to two-wav 2A148 Tune (air nrake foot control va]ve toaash tee) ~1I11l check valve) -tractor trailer equipment Tube (air brake foot control valve to manifold 2A014 Tube (brake air relay to forward rear axle brake 2586

fitting) 'tube) Tube (air brake foot control valve to parking brake 2A084 Tube (brake air relay valve to rear brake 2A289

chec k valve) tube connector) Tube (air brake foot control valve to rear 2540 Tube (brake air reservoir to elbow) 2A109

tee)-2nd section Tube (brake air reservoir to tee) 2Al26 Tube (aIr brake foot control valve to rear tee or ~1I1\j Tube (brake air reservoir to transmiSSIOn aIr tee) 2A060

union)-lst section Tube (brake air straight) 2A540-3

Tube(airbrakel00tcon.valvetoreartee~ndsectior 2923 Tube (air brake foot control valve to rear tee)- 2540 Tube Ibrake booster connecting) 2B052

2nd section Tube (brake booster reservoir to booster) 2A028

Tube (aIr brake foot control valve to trans. aIr tee) ~-Ztl;:S7 Tuhe (brake booster to tee) ~A140 585

Tube (air brake hand control valve to check valv~ 2581 Tube (brake check valve to trailer shut-off valve) 2B226

Tube (air brake manifold to pressure gauge) 293U Tube (brake foot control valve to tee) 2B229

Tube (air brake quick release valve to union) 2A059 TUbe (b.raKe lOot control valve to trailer bfjj]{e <lA'Hj;j

2-2912 air shut off valve) ._ .- .----- -

FORD TRUC/( 'ARTS SECTION 10 7

INDEX SECTIONS 20, 21,22, 23, 24, 26 and 28 - BRAKE SYSTEM - continued

PART NAME I GROUP PART NAME GROUP

NUMBER NUMBER

Tube (brake hand control valve) 2B067 Tube (reservoir to trailer brake air protector valve 2592 Tube (brake manifold fitting to check valve) .2B234 '!'u1Jtllreserv:oil'~trailer br<lke~J_p!otector valve2 2-2942 Tube (brake manifold to control valve) 2B233 f----- --

Tube (brake manifold to front brake limiting valve) 2B235 Tube (tee to manifold fitting)-air brake 2A078 Tube (brake manifold to trailer shut-off valve) 2B228 Tube (tee to trailer brake air protector valve) 2A198 TUl:Jdl:>r'ake_ m~nj.lold to_unionL ____________ 2A141 2-2540

----- ------------ ----- - -- --

Tube (brake pressure reactivator to trailer snut-off) ::!B::!3::! Tube (trailer brake check valve to air shut off valve) 2A480 '1'l1hf' (hrake reservoir union to tee! 2A278 --tube(tr-aller b-raKe emer-gency -aIr supply valve

- ZAI'I7--Tube (brake shut-off to_r~~<:.!!vator valve) _____ 2B227 to union) ------

Tube (trailer brake emergency valve to reactivator 2B236 Tube (brake vacuum bOoster control valve to center 2-2333 valve)

control valve) Tube (trailer emerg-encyalrsupply valve to manifold) 2539 Tube (brake vacuum booster control valve to 2-2337 Tube (traile!'....tllllergency air supply valve to union) 2-2541 hydraulic cylinder) -------

Tube (brake vacuum bO:Jster reserve taM to tee) ~;S'lts Tube (two way check valve to trailer air protector va~ve) 2 -2 53 8 Tube (braKe vacuum booster tee to lront wheel tee) 2A143 -----------_._- --- ------ -- - ,-----Tube (brake vacuum pump to check valve) 2A152 Tube (union to reservoir)

~- -._-----_ .. _----12-2202

Tube <EJ:'ake vac.t:.um strai!f~tL _______ -

2A5'~~ ___ Tube (union to trailer brake air protector val",,) : 2538 ----------- ---- --------- ------- ---6;-- -

Tube (check valve to trailer brake air protector 2576 Tuoing (copper) valve)

to slave cyl. )-----Tuomg (steel) -brake & fuel lines

12269

Tube (clutch master cyl. 2-2443 ------ ------- ---- ----- -- - ---

"U" Bolt (brake air reservoir to mounting bracket) I 2300 Tube (compressor governor to brake air foot 2A287 -8

control valve) Valve & push rod (air brake foot control) 2A456 Tube (dash tee or foot control valve to air 2913 Valve and stop lamp switch assy. (brake control) I 2575 compressor g~vernor)

__ "_W________________ _ ______ , _____ -------------1-------

--------- --- ----- I

-- ------ 29TI>.--- Valve assy. (brake air foot control) ·2A270 ThlJe\engine-fo ali: compressor}-water-- i 2886 TUbe- ( !)ngl~e to=-~inpr~~~r~~at~I)~tlIl!iilli_eii~.

---_.-. ~-w7'i--- Valve assy, (brake air hand control)

--2949

--- ------

Valve assy. (brake air limiting control) , 2A208 Tube (l1exible hose to manifold) 2-2338 Valve assy. (brake booster control) : 2A238 Tube (forward rear left wheel air brake) 2-2200 Varveassy~ (braKe-boostervic. cneck)

- --~!f65-

- -

Tube (forward rear right wheel air brake) ~-2265 Valve assy. (brake maste-r-cylinder) 12178 Tube (front brake air limiting control valve 2A210

-- -------- -- --- -- 1--- ----

to foot control valve) Valve assy. (tractor brake afr protector) 12951 Tu~~j inta~ l1lanifold~o che~k _",_~V!)) ____ ~5till ___ Valve assy, (trailer brake emergency aIr supply) ~ 21122'1

Valve assy, (two way cheCk}-tractor eqUipment ~:rt:l

Tube (manifold fitting to air compressor governor) 2976 Valve assy. (vacuum pump oil check) 1~~563 ---

2A116 ---------- ---- ------

Tube (master cylinder to rear tube connector) 2-2271 Valve (air brake quick release) 12A095 2A199 Valve (air reservoir safety) ,2A550

I Tube (parking brake air chamber connecting) 2A755-6 Valve (rear wheel parking brake air control)-in cab 12A622 Tube (parking brake control valve to fooi 2A726 Valve (rear wheel parking brake release) ,2A744 control valve) I

Tube (parking brake control valve to reactivator 2A810 Washer (brake air boostercontrolvaTve diaphragm) 2372 valve) Wasner (brake shoe anchor pin) 20~li

Tube (parking brake control valve to release valve) 2A727 Washer (brake shoe hold down spring) 2066 Tube (parKlng braKe rear wneel)-L. tl. U\·I:lli Washer (brake vacuum booster piston stop)

I 2B023

1'l\b~Jpal'....kiEg bra,ke rear ..v:ll.~l)-=-It. H. 2A728 Washer (orake vac. oooster push roo seal retamer) 2385 -- ---- -- ---- --

Washer (tront air brake camsnaft thrust) I ~~;Sti Tube (rear rear left wheel air brake) 2268 Wasner (l'ron{ au 6raKe snoe actuator lOCK) 2BUlU Tube (rear rear right wheel air brake) 2267 Washer (front orake shoe retaining pin) ~U:l;S

Tube (rear wheel parking braKe control valve to 2A720 Washer (front brake slioe retainer pin)-He' ~Uts'l

foot control valve) Washer (rear air brake adiuster retaining) . 2130 Tube (rear wneel parKlllg brake control valve to ~K(2b Wfl:.~~ (rear air brake e~m~hai!L ____ 2235

-- ---- - - ------".

foot control valve supply) -- _. - - ----- -- Weage assy. (lron{ afrorake actuatmg) wlJul,l. Tube (relay valve to rear wheel brake tube conn.t 2-2269 Wedge assy. (rear air brake actlla.til1gL ____ 12B024

- --- ---

-'tUbe (reservofrto air biiiKefooCcontrofVaTveT - 2(120-- -

Juoe_ (r!)~tll"voir.!o relay "<ti,,e) 2-2911 ~~r~,:t~sY~0'a<:.u.tI..m3auget __ -------_ .. _-- 2A~U'I _ -- --- ---------

- - - ----- ---- --- ----- ---- . - -- -- --------- _. ----- ----- -- -- ----- -- ._----

- ._- ._-- -_.- ------ -- /---- ----- ---- --------- - ---- ----.--- --- -- ---_ .. -~---

8 SECTION 10 FORD TRUC/( PARTS

HOW to IDENTIFY WHEELS, RIMS, FLANGES and LOCK RINGS

1. Many wheels and rims may be identified by a stamping number. When the stamping number is known, refer to the Guide on Page 9 for the appropriate service part number. 2. When the stamping number is not known, wheels and rims and their related flanges and lock rings may be identified as follows:

(a) Determine the type of wheel or rim from the illustration below. (b) Determine the size of the wheel or rim. If this is not known, check the tire size and refer to the Tire Size to Wheel

or Rim Size Chart on page 10 of this section. This chart also lists the various truck series on which the tires and their related wheels or rims are used.

(c) When the size of the wheel or rim is known, refer to the Wheel,Rim, Flai:ge and Lock Ring Ch:lrt (pages 11 and 12).

TYPICAL WHEELS, RIMS AND RELATED ITEMS

TYPICAL DISC WHEEL TYPICAL FRONT SPOKE WHEEL OR HUB ASSEMBLY

ONE PIECE DROP-CENTER RIM

TWO PIECE SEMI-DROP-CENTER RIM

RIGHT HAND 50 ADVANCED RIM

TWO PIECE FLAT BASE RIM

THREE PIECE FLAT BASE RIM

(9-67)

PILOT MOUNTED DISC WHEELS

FRONT WHEEL ATTACHMENT

1007 1015

DUAL REAR WHEEL ATTACHMENT

- -~ ~-'-+-5" OFFSET I I

BALL SEAT MOUNTED DISC WHEELS

1007 1015

FRONT WHEEL ATTACHMENT

(9-67)

- 4--1/2" OFFSET I

1109

DUAL REAR WHEEL ATTACHMENT

P.S156

P·5387

<i OF RIM <i OF RIM P-7585

SECTION 10 9

YEAR ! MOD E L DES C RIP T ION ! QTY.! PART NUMBER 1001 GASKET - REAR WHEEL IEARING RETAINER or REAR AXLE SHAFT ~ 61/ W­sv--

~IOO F-P100

IF-Ploo, E200 IF250 (4 x 4)

B-F-N-P500, C500/550

-w-- F250/350,P350/~OO,E300

Rear Drake carrier pIate-~ 7/S" 1.I5.-~ noles

Rear wheel-3 7/32" I. D. -5 holes Rear brake backing plate-3 7/32" I. D. -4 holes Front wheel-3500 lb. Dana front axle - 5 bOlt

holes 3 3/4" circle-Also refer to Parts List Section 40A

Rear axle shaft-4 ' LD.-5.53" O.D.-IM, 13M axles

Rear axle shaft-3. 35" I. D. -4. 70" O. D.

:1 2

, 2

h-II ff W-!T700 I Rear axle Shatt-4 1/2 1.v.-o 7/1l O.D. 1"1r'l

57/ I B-C-F-N600/700 i 4 ,

CIAZ l(nH-A C5AZ 100I-A C6AZ 1001-A CITZ 1001-A

ASTZ lOOl-A

A8TZ 1001-B PI B41:6 lUUI-A

~I F350,P4001 Rear axle shaft-8 holes-3.51"I. D. -4.89"0. D. -! 2:' 57/ !P350 (H/D rear axle) 4.12" bolt circle I~II_~~~~~~ ~~~~I~;;~F700/750'N600/750 ~: I A8TZ lOOl-C

B5TZ 100l-A

58/ ,T700 (H/D axle) 601 IB-C-F600 (16M rear axle) 61/ I HT850 /950, (HT850 /950-Diesel exc.138" W /B) i 8 61/ ICT-T800/850, NT850 I 8 I

:t ~~?! :~800 /850 I'R"'e::;a:=r--oax;-::r.le~shC::ilf~tr-T12""h~olr;:e-;os_---;~'."-5 ,,,-, TL""D'. -"6~.1"'2m, '''O'''.''D'. --I~ --'An'8""T"'Z'---'i"'o"'O"--1-~D"-57/ I CT-T800/850,NT850 I 5 1/4" bolt circle 4 . 60/ IB-C-F-N700/750 I IBM axle i 2 I 61/ IHT850/950,(HT850/950-Dieselexc.138"W/B)i ' 4 . 57/

m

l'C:':F900/fOOO,N850/1000 ' \ Rear axle shaft-5 5/8" LD.-8 1/2" O.D. 1-2-'I'--'B=3~T~Z~1~O~O~I--'A-58/ ICT-T-NT950 i 4

58/59 IC-FlIOO I I 2 I 60/ IC-F800/850 , 2 . 61/62 ! H950/1000, HT850/950 ,(HT850/950-Diesel, ; , 2or4

/except 138" W /B) I I \

63/ HT95.o ,N_T850, HIOOO " '" '" 2or4 58/ i C-FllOO (H/D rear' axle & extra iff6 rear - 'Rear ax-fesnaft.:flnoles.:tl"f.D.-8.38....-0.b.:7"-j 2

!

SpringS) bolt circle I 60/ C-F-NllOO I 2 60 C-F1000 (H/D rear axle & E/H/D rear springs) ! 2

63/ IT950 (except 158" W/B) I 2 I ,

LlB8TZ 1001-A

1007 WHEEL or RIM IDENTIFICATION CHART (See instructions for identifying wheels,. rims, etc, on page 8 of this section.)

IDENTIFICATION PART NUMBER IDENTIFICATION PART NUMBER

DX 45522 C3TZ 1007-E

25372-11 B7T 1015-B __ 24~92~8~0~ __________ -+-=B~9T __ ~1~00~7~-~A ________ __ 49380 7RY 1007

E 5487-C I ClTT 1007-C

E 5780-A C1TT 1007-D DX 45524 C3TZ 1007-F

25375 I B4Q 1007 -A 25376 B4T 1007-A 59350 8TH 1007-A

RA 25438-5 B5QH 1007 -C 65340 *C3TZ 1007-H RIB C3TZ lOO7-L 25440 C4TZ 1007-F 65340-D C3TZ 1007-L 25441 C4TZ 1007-F 68410 B4T 1007-A

RA 25441-9 C4TZ 1007 -F 68500 B4Q 1007-A 25442-5 B6QH 1015-B 68600-1 B5Y 1007-B 25461-7 B6T 1015-D 70610 C1TT 1015-A

RA 25495-3 B6QH 1015-C 70740 B6Y 1015-B RA 25668 B9T 1007 -A 71340 B6QH 1015-B

25740 C4TZ 1007-F 71410 B6D 1015-B RA 26015-4 C4TZ 1007-G 72050 B6J 1015-B

26027 C4TZ 1007 -G 73230 B8Y 1015-A C3TZ RH 26487 73240 I B8D 1015-A 1007-E

C4TZ 1007 -A

RA 26493 . C3TZ 1015-A I C3TZ RA 26494 1015-B

26551 26723 B6QH 1015-B 31031 B9TZ 1015-A 34706 8TH 1007 -A - ._.

"" Use WIth conventIOnal & two speed axles

10 SECTION 10 'tliD TIUC/( PAITS 1007 - continued WHEEL or RIM IDENTIFICATION CHART

(See instructions for identifying wheels, rims, etc., on page 8 of this sec ion

IDENTIFICATION PART NUMBER IDENTIFICATION PART NUMBER

79870 79980 79980-14 80060 80650 86120 86220

TIRE SIZE

86770 I C4TZ 1007-N I C3TZ 1007-E 1007-F 90200 C4TZ 1007 F

*C3TZ 1007-B RIB C4TZ l007-F

C4TZ 1007-G ____ ~9~0~2~10~------------~C~4~T~Z~ .. ~1~0~0~7~-F~---------

90240 C4 T~Z __ -,,1:.=-:00:-=7:--G~ ________ _ 90270 C4TZ 1007-G C3TZ 1015-A

C4TZ 1007-F 90340 C4TZ 1007-A C4TZ 1007-G F 200005-22575 CITT 1015-D

TIRE SIZE to WHEEL or RIM SIZE CHART (See instructions for identifying wheels, rims, etc., on page 8 of this section.)

WHEEL or RIM

SIZE MOD E L TIRE SIZE

WHEEL or RIM

SIZE MOD E L

G78 x 15 15 x 5.5 1"100 9.00 x 22.5 22.5 x 6 B-C-F -N500/700, T700 9.00 X 22.5 22.5 X 6.75 B-C-F -N600/750, NT850,

6.00 X 16 16 X 5 F100 CT-T700/850 6.50 X 13 13 X 4. 5 E100 9.50 X 16.5 __ 16. 5_x §;~ F250L350, P}50(.400 6.50 X 13 13 X 5.5 EI00 10-:<)0 X20 2(J X 7 c-Ir-C-F-N7()0/1l0a -~-6.50 X 16 16 X 4.25 FI00 CT-T750!950, HI000, HT850/950, 6.50 X 16 16 X 5 F-PI00, F250 NT850/950 6.50 X 16 16 X 6 F250 lQ.OO-xW--" 20 xD--J-B~F~N'IO()/IHlO,CT:':T7~079so; 6.50 x:OO 20 X 5 F-B-P500, C550 HlOOO, HT850/950 , NT850/950 6.70 X 15 15 X 5 F-PlOO 1~:OO--x22- -~ x7~S- C:F~lIf85(j!nOO-;CT::T80079W;--6.70 X 15 15 X 5.5 F-PI00 HIOOO,HT850j950,NT850j950 6.95 X 14 14 X 5.5 EI00 10.00 X 22.5 22.5 X 6.75 B-C-F -N600/850, NT850, 7.00 X 13 13 X 5.5 E100 CT-T700/850 7.00x14 14 x5.5 E100 10.00x22.5 22.5x7.5 B-C-F-N700/850,NT850, 7.00 X 15 15 X 5.5 F-P100 CT-T700/850 7.00 X 16 16 X 6 F250 11.00 X ~U ~U X 7.5 C-J:<'-NtlUu/1100,CT-TBOO/950, 7.00 X 16 16 X 5.5 F250/350 HI000,HT850/950,NT850/950 7.00 X 17 17 X 5.5 F250 lLOOx2020 x~-C--F-N8507fioo~CT856!950,---7.00 X 17.5 17.5 X 5.25 F100/350, P350/400 H1000, HT850/950, NT850j950, 7.00x18 18 x5 P500 '1'800/950

_7.00 ~ 20 __ ~x 5 __ B-F-N500, C550 lI:lJO-x-2:r 22 X '1.5--' C-F-Ng5(j/nOO,CT-~T95O-;-H1OO0-;-7.Olix20 Jt:u X S- ~~500-------- '----- HT850j950,NT950

7.00x22.5 22.5x5.25 B-F-N500,C550 11.00x22 22 x8 C-FllOO 7.10 X 15 15 X 5 F100 11. 00 X 22.5 22.5 X 6.75 B-C-F -N750/850, NT850, 7.10x15 15 x5.5 F-P100 CT-T750/850 7.35 X 14 14 X 5.5 E100 11. 00 X 22.5 22.5 X 7.5 B-C-F -N750/1100, HT850/950, 7.50 X 13 13 X 4. 5 EI00 HI000, NT850/950, CT-T750/950 7.50 X 14 14 X 5 E100 11. 00 X 22.5 22.5 X 8.25 C-F -N800/1100, HT850/950, 7.50 X 16 16 X 5.5 F250/350, P350j400 HlOOO, NT850/950, CT-T800/950 7.. 50 X 16 __ ~ X 6 F250 11. 00 X 24.5 24.5 X 7.5 F900/1100, C1000/1100 ~-:OOXI'l 11 -X-5.5 FZ501350;P350]400-------- 11.00x24.5 24.5x8.25 C-F950/1100,T950

7.50 X 20 20 x6 B-C-F-N'5001700,T"'"7""00~~~- ~Ox--zO iZu xtl C_J:<'-NtlOOjllOO,CT-TIIOU, HlUUU, 7 75 X 15 15 X 5.5 F-PI00 HT850/950,NT950 8.00 X 14 14 X 5.5 E100 12.00 X 22.5 22.5 X 8.25 C-F -N800/lIOO, HT850/950, 8.00 X 16.5 16.5-'" 6-----F250!35(j,P350740(j---~------ HI000, NT850/950, CT-T800j950 8.00 X 17.5 17.5 X 5.25 F250/350, P350/400 12.00 X 24. 5 24.5 X 8.25 C-F950/1100, T950 8.00 X 19.5 19.5 X 5.25 F250/350, P350/500 15.00 X 19.5 19.5 X 11. 75 B-C-F -N750/850, NT850, 8.00 X 19.5 19.5 X 6 P500 CT-T750/850 8.00 X 22.5 22.5 X 5.25 B-F-N500, C550 15.00 X 19.5 19.50 X 12.25 C-F800/850, N -NT850,

S.OO X 22.5 22.5 X 6 B-C-F -N -P500/700, T700 CT-T750/850 S.25 X 15 15 X 5.5 F100 15.00 X 22.5 22.5 X 11.75 C-F-N95~1100,CT-T800/950,

Il:-rs-X 15 15 x--s~--s--- F=1'IOO'--------------- ~____,_,,--~~_h_..___:____,..___....-+-H;,_:1~0~00:;,:;H~T;;:S~5~0 /'..:9:.::5.::,0'-.:, N:.:.T=-8,--,5:.::0-,-/,--,95=-=0~_ 8.25 X 20 20 'X 13 --- B:C-F-N500l'iOO,-"T~70~0~~~- i5.00 X 22.5 22.5 X 12.25 CT-TSOO/900 8.25 X 20 20 X 6.5 B-C-F-N500!850, 16.00 X 19.5 19.5 X 13 B-C-F -N750. T750

CT-T700/850, NT850 16.50 X 19.5019.50 X 12.25 C-F80o/.S50, N -NT850, CT-T750j850

6.00 X 16 16 X 4.25 FI00

~216._s...~5 X_~'l5 F'~L~~O,P350j40~ ____ ~_ 16.50 X 19.5 19.5 X 13 C~F-N750/1100,HT850/950 • ... vv X "V x. B-v-F-Nmm-/ll5O,-CT-T700/S00 HI000, NT850/950, TSOO/950,

-S,OOx '2O'H 20 u

X r- f-B-C-F-N600/-"8"'5"0,---C'"T"-"T""'7=OO"/=S~50",- CT750/950 lS.00 X 19.5 19.5 X 14 B-C-F -N750/1100, HT850/950, NT850 H1000,NTS50/950,CT-T750/950

'tiRO TRUCI( 'ARTS SECTION 10 11

1007 - continued

WHEEL, RIM, FLANGE and LOCK RING CHART (See instructions for identifying wheels, rims, etc., on page 8 of this section.)

WHEEL BOLT VENDOR PAR T N U M B E R YEAR OR TYPE HOLES CIRCLE CODE I SIDE RING OR FLANGE I RIM SIZE (INCHES) W H EEL OR RIM LOCK RING

DISC WHEELS AND RINGS FOR TUBE TYPE TIRES 57/ 15 x 5.5 S.D~C. 5 5.50 TAAA lll07-B 7RC lll99

.. - m. c. 57/62 16x4.25 5 5.50 8C 1015

57/ 16 x 5 D.C:--· r· 5 5.50 B4TZ 1007-A Internal hub cap fastenine: -

57/ 16 x 5.5 S.D.C. 6 7.25 C:5TZ lUU7-J... 8J 109\1

57/ 16 x 5.5 S.D.C. 8 r6.50 B 6B7TZ 1007-A 8J 1099

57/ 16 x 6 D.C. 8 6. 50 K B9TZ 1015-A

.... _-_.-~PC. 57/ 17 x 5.5 6 7.25 B5Y 1007-B 7RY 1099

57/- 17 x 5.5 2 p·C. 8 6.50 7RY 1007 7RY 109-9 ~--- .~~~-~ - ---------- ----.------.. - .. ~-

57/ 18 x 5 2-PC. 5 8.00 7RTL 1007 7RTL 1099 ,

.~ 1----.--," 57/ 20 x 5 2 PC. 5 8.00 7RT 1007 -A 7RT 1099-A

, -- -- -- -

20 x 6 5 8.00 8TH 1007 -A 7RT 1099-B 57/ 2 PC. 57/62 20 x 6 -RH-5~ ~6--6.'75-----

B4Q 1007-A -~RT 1099-B~- ----

63/ ~U x 6 HH:>OA 6 15.'/:> \;;jTl; lOU'/-l!; '/HT 101:111-13

--=-----8-:-75-~ _.

57/62 20 x 6.5 -RH5()A- 6 B4T 1007-A 7EQ 1099-B 63/ ~U x 6.:> HH:>OA I) 15,'/:> \;;j'1'l; lOU'/-I" '/l!;1o! lOl:Il:I-13 I);j/ <lU x I).:> <:I PC A I) 15,'/:> 1" \;4'1'l; lUU'/-N \;4'1'l; lOl:Il:I- J...

63/ 20 x 6.5 2 PC.D 6 8.75 B C4TZ 1007-N C4TZ 1099-H 63 20 x 6.5 3 PC. 6 8.75 NUTl!; 1 8Q 1099 8Q 1021 57/63 20 x 6.5 2 PC. 8 10.00 7EQ 1007-B 7EQ 1099-B

20 x 6. 5 .. _-

rIO 11. 25 C1TT 1007 -A 8Q 1099 8Q 1021 57/63 3 PC.

6:5/ ~U x 7 ~ PC.A 6 !S.I;) .1" C4TL. lUU·I-1\. C4TL. 101I1I-J... 6:5/ <:IU X 7 ~ PC.A 6 15.7:> B V:lTL. lOu'I-A ViTL. 101Il:I-H 63 20 x 7 3 PC. 6 8.75 NOTE 1 7EQH 1099 7EQH 1021-B 57/62 20 x 7 3 PC. 8 10.00 B5~H 1007-B 7EQH 1099 7EQH 1021-B 57/63 20 x 7 3 PC. 10 11. 25 I B5QH 1007-C 7EQH 1099 7EQH 1021-B

63/ 20 x 7.5 2 PC. 10 11. 25 F C4TZ 1007 -F C4TZ 1099-A I 63/ 20 x 7.5 2 PC. 10 11. 25 B C4TZ 1007-F C4TZ 1099-J I 57/63 20 x 7.5 3 PC. 10 11. 25 B8QH 1007-B 8QH 1099 I 7EQH 1021-B 63 20 x 7.5 &--"3PC. 10 11.25 r----.c3TZ 1007-B C3TZ 1099-B C3TZ 1021-B

RjB C4TZ 1007 -F

57/ 20 x 8 3 PC. 10 11. 25 B9T 1007-A B9T 1099-A 7EQH 1021-B 61/ 20 x 8 • 3 PC-. 10 11.25 F *C1TT 1007-D B9T 1099-A 7EQH 1021-B

63/ 22 x 7.5 2 PC. 10 11. 25 F C4TZ 1007-G C4TZ 1099-B

63/ 22 x 7.5 2 PC. 10 11. 25 B C4TZ 1007-G C4TZ 1099-K 57/63 22 x 7.5 3 PC. 10 11. 25 B8QH 1007-A TUAA 1099-A TUAA 1021-A 61/ 22 x 7.5 • 3 PC. 10 11.25 F * C1TT 1007 -C TUAA 1099-A TUAA 1021-A 63 22 x 7.5 3PC. 10 11.25 *C3TZ 1007 -A C3TZ 1099-A C3TZ 1021-A

RjB C4TZ 1007 -G 59/62 22 x 8 3 PC. 10 11. 25 *C1TT 1007-B TUAA 1099-A TUAA 1021-A

F Firestone R1dd B E K ~else Hayes y & HI TenSile '" Alummum A Pilot mounted & Ball seat mounted

6 .50 Offset NOTE 1 - Only two piece wheels are available for service. Flanges and lock rings are available separat-ely for both two

and three piece wheels and rims,

12

YEAR

SECTION 10

1007 - continued

WHEEL, RIM, FLANGE and LOCK RING CHART - continued

W H EEL OR RIM SIZE

(See instructions for identifying wheels, rims, etc., on page 8 of this section.)

W H EEL OR RIM REMARKS

61/ 13 x 5.5 -~-- ~-5~-- 4-:56~~-----C3UZ--=-1"00"'7;;-~-;Ono-----1--~-------------~--

61/6~1-~4_x~___ _~-f---5 4, 50 B7A 1015-A

61/62 13 x 4.5 I: 5 4.50 C1UU 1007 A

61/ 14 x 5.5 --f---5 - -4.50 BSA 1015-A ~'-'--+--;::E;-x-ce-p--;t-;S;;-u-p-e-r-:-vC:-a-n---------57/62 15 x-5 --~- D. C.--~- ~ -5 -- -5-:-5-0- ---- --B5C-TOf5-=-P:-~--~'~1----'-

63/ 15 x 5.5 D. c.--f-- 5 --1-5.50---- C5TZ 1007-D -"H"/""D-o-n-'F==-C-P=-10"'0c-l-n-te-r-na-l~h-u~b-c-a-p----

=R L fastening 57/62 16 x 4.25 - D. C~-- - 51 5:50---~ SC 10"'1-'5-----+----=--------------

57/ 16 x 5 D.C. --r--~5-- ~5:50-~---- B4TZ 1007-A I Inte-r--na--;-l--;-h-u'-b-c~a-p fastening

57/ 16 x 6 - ~~. c.._~~=.:s_= --.!. 50 ~_ __ B\JTZ 1015-A ~--=-----

~~j ~ ~ ~ ~ : ~~ ~~ 1 ~: -~~--~-~- -t ~--~ ---~-~-:~:;~:i;z_~~ .. ~c-,;~;~.:;~~---A.A.-----------~-_I~---~D~ .. ,-u:-::a~~l~'-R:e~~a-r~s;;~~~~~~=~~~~~~~~~~~~-57/ 17. 5 x 5. ~:_c-:: ~~=-~_~_ ~A5 __ ~_I ____ iBnSO'Yr;_-1,A01,,5,~-,A:__---t___;S;_;_ln-:g=_;1-e_:R:_e-a_r_s _________ _

57/ 17. 5 x 5. 2 5 ___ ~<::-'~- __ ~_ 6. 50 --+----r;BB-;;-S6-;;DDC--.11,;;00'"11"55-;~ABo;-------t--'S=i=n"'gl:.::e-'R"'e=a~r'_"s~ _________ _ 57/ 19.5x5.25 D.C. S 6.50 57/ 19.5 x 5.25-- D. C. ---6~+-~7'-;. 2"5'---+---=B6Y 1015-B 57/ 19.5 x 5.25~-'rs.C. ~-1--~5- 8.00---- B6J 1015°--'A-----t------------------57/ 19.5 x 6 - n:-c--.---f--5 fl:OO B6J 101"5-;-Br;--~----t-----------------

___ L ________ 1--5-

57/ 22.5 x 5.25 D.C. -8.-60~ B6T 1015-B 57/ 22.5 x 6

~- -~~---1-- 5- __ ~oo-~ ___ B7T 1015~A D.C. 57/62 22.5 x 6

.~~- -T)--:C:-J; 1-- 6 - --B7T 1015-B S.75

ti3/ <:<:.:> x 0 V.C.l!. ti 11.'1:> C3T:G 101:>-13 57/62 22.5 x 6.75 D.C. S 10.00 B6Q 1015~A

57/ti2 2<:.0 x ti.70 D.C. 6- ti ~. 0'-10 !:SOT 1U10-V

61/ 22.5x6.75 D.C. 10 11.25 C1TT 1015~A

0.0<:1 unset

ti3/ <:<:.:> x 0'-1:> V.C.l!. ti 1 1l:ltl C3T:G 1Oltl-A

57/62 22.5 x 7.5 D.C. S 10.00 B6QH 1015-A 22.5x7.5

- --;--10 11. 25 B6QH 1015~B 57/ D.C.~_

61/ 22.5x7.5 D.C. t----ro- 11. 25 C1TT 1015-D Aluminum

-~!!-- <:<:.:> x Il.<::> lJ'C' _ 10 __ 11.<:0 _l:I.~H 1O:~:C __ ---------- -- -----+--~-- .--~------~---- .--~----~- - ------

o'l/tiU <:4.:> X 'I.:> V.C. 10 ll.<::> 'j\'BO"-!tl lUl:>-V

57/60 24.5xS.25 D.C. 10 11. 25 *BSQH 1015-A

---_ .. - -- ._- --.--.~---- ._-------- ___ .~ __ ~_L __________ ~ ____ ~ __ ___' __________ .. ___ ~ _______ ~ ____ . __

WHEEL VENDOR SIDE RING YEAR or T Y P E SP ACER WIDTH

CODE WHEEL or RIM PART NO. or LOCK RING PART NO.

RIM SIZE FLANGE P ART NUMBER

RIMS AND RINGS FOR SPOKE WHEELS or HUBS FOR TUBE TYPE TIRES

57/63 20 x 6 3 PC. 4.00 * TYAA 1020-A ST 1099-C 8T 1021~C

UseSQ 1020

57/63 20 x 6.5 3 PC. 4.00 8Q 1020 SQ 1099 SQ 1021

57/63 20 x 7 3 PC. 4.00 BSQH 1020~C 7EQH 1099 7EQH 1021-B

57/63 20 x 7.5 3 PC. 3.62 B8QH 1020-A SQH 1099 7EQH 1021-B

57/ 20 x S 3PC. 3.62 B9T 1020-B B9T 1099~A 7EQH 1021-B

57/63 22 x 7.5 3 PC. 3.62 BSQH 1020-B TUAA 1099-A TUAA 1021-A 57/63 22 x S 3 PC. 3.62 B9T 1020-A B9T 1099-B TUAA 1021-A

RIMS AND RINGS FOR SPOKE WHEELS or HUBS FOR TUBELESS TYPE TIRES 57/ 22.5 x 6 D.C. 4.00 B6Q 1020-G 57/ 22.5 x 6.75 D.C. 4.00 B6Q 1020-E 57/ 22.5x7.5 D.C. 4.00 B6Q 1020~F

57/ 22.5 x S. 25 D.C. 4.00 B6QH 1020~C

57/60 24.5 x S. 25 D.C. 4.00 B6QH 1020-E

57/60 24.5x7.5 D.C. 4.00 B6QH 1020~D

l!. .1:'1 Or mounte<1 .t. BaH seat moumea

FORD TRUC/( 'ARTS SECTION 10 13

YEAR 1 MODEL 1 DESCRIPTION 1 QTY·I PART NUMBER

lAOll SPACER - REAR WHEEL INNER BEARING ~/T-NT950 (42DP & 42RP axles) 1 3 1/4" I. D. -4 3/8" O. D. -11/16" thick 1 4 ! C2TZ 1A011-A

-I 1 1 1

1012 NUT-HUBBOLT-FRONTandREA,.R~mn~ ____________________________ __ ~IF-E-P100 r1/2"-20 I~I- B 1012

63/ IF350 I 32 I 57/ IF250,P350/400 1

32 57/ F100/250 (Pickup) Spare wheel carrier 110r3 57/ F100 Platform & Stake, F350 Pickup, P350 1 2 1

I I I I lA012 PIN - REAR WHEEL INNER BEARING SPACER

~IT-NT950 (42DP & 42RP axles) 1'1,/n,2'" 'i"::loc::-n-=-g-Lta=-=p:-:e=r::-:ed:.-----------I,_4_1 C2TZ 1AOI2-A ---1--------- -._-------- -------1-- _.- ------.-_.- ------------[ 1 1014 HUB ASS Y - FRONT SPOKE WHEEL - Also see Spoke Wheel Chart with Group 1109

For model usage refer to Front Hub & Drum Chart under Basic Group 1104

STAMPED NUMBER PART NUMBER STAMPED NUMBER I PART NUMBER ---

F20-58A C7TZ lO14-A F22-49A

I

COTT 1014-A F20-58B C7TZ 1014-G F22-57A B'iQH ~OlA-B 1859 C3TZ 1014-A F22-64A B8QH 014-B F20-48A B6Q 1014-A ---F22-89 C3~Z ~gi1=~ F20-49A B6Q 1014-B F 8301 A6 BrT F20-57A B7QH 1014-A F 8882 *C3 Z 14-D F20-58A B7QH 1014-C

I RIB C3TZ lO14·E

F20-64A B8QH 1014-A F 8965 C4TZ 1014-E F20-88-A C3TZ lU14-A F 9159

I

C3TZ 1014-E F20-89 C3TZ 1014-C

YEAR I MODEL I DESCRIPTION I QTY.! PART NUMBER

lA014 SPACER - DISC WHEEL HUB 62/ - 1 C~F-N~-T860/1000, H-HT850/1000 1 Front-S 13/16" LD.-13172''O:"D.--=10 hole----

1 11 1/4" bolt circle I 2 I C2TZ lAOI4-A

1

1 C-FSOO/I000,H-HT850/1000 1015 WHEEL ASSY. - DISC

i Rear - rtefer' to the 1007 Wheel Chart

! 1

62 20r4

1020 RIM ASSY. - SPOKE WHEEL _ REFER TO WHEEL CHART· Refer to the 100'/ wheel Chart lA020 PLATE and PIN ASSY. - LOCKOUT HUB RETAINING _ Also Refer to Parts List Section 40A

~IF250 (4 x 4)-3.5M front axle 1 For Dana (spicer) hub 1---Z-I,q"'o"'C"IT"'Z~InA[7'O""2"'"O--cA'-

~IF250 (4 x 4) 1 Bolt (plate to hub housing)-3/8"-16 x 3" 1 6 1 376122-S(BB166D) 1021 RING - WHEEL RIM LOCK ~ Refer to 1007 Wheel Chart --1-- 1--------------lA021 GASKET - LOCKOUT HUB HOUSING - Also Refer to Parts LiEt Section 40A

-6V-I=F~25~0~(~4c:..x=-;4J-3.5M front axle 1 For Dana (Spicer) hub .--.----_.----1-2 -I %C1TZ 1A021-A

I I I I lA022 RING and CAM BODY ASSY. - LOCKOUT HUB _ Also Refer to Parts List Section 4M:

~1=F~2~50,.--;.(4;.:..:cx 4f-3.5M front axle 1 For Dana (Spicer) hub 1 2 l-q07o"C"I"'T"'Z"--'-IA"""02"'2'-'A:-lA023 BUSHING - LOCKOUT HUB - Also Refer to Parts List Section 40A

61/ IF250 (4 x 4)-3.5M front axle I For Dana (Srncerj hub 2 I %CITZ IA023-A lA024 SPRING - LOCKOUT HUB - Also Refer to Parts List Section 40A

61/ I F250 (4 x 4)-3.5M front axle I For Dana (Spicer) hub -------------.'--,;2.---;I'q07o"'C"lmT"'Z:-1"A"O"'2"4--A'----I 1--------------'1-1

lA025 PIN - LOCKOUT HUB RETAINING CAP _ Also Refer to Parts List Section 40A 61/ ,F250 (4 x 4)-3.5M front axle I For Dana (Spicer) hub -----------,1 :-2"'--'1 "%"C"'I'"T""Z"'--;ITA""'02"'5'---'-A

lA026 HOUS ING ASS Y. - LOCKOUT HUB - Also Refer to Parts List Section 40A ~-I'MF"'25""'o,,(r,r4-=x~5MfrOii.taXTe-----------I~na (SpIcer) hub ----.---- -------r·"2--i 9'0CITZ lA026-A ---- - 1 '-'1-----

lA02B SLEEVE and RING ASSY. - LOCKOUT HUB _Also Refer to Parts List Section 40A W-IF250 (4 x 4)-3.5M front axle 1 For Dana (SpIcer) hub I-z--I %Cl1'Z lA028-A

lA029 KNOB - LOCKOUT HUB ACTUATING _ Also Refer to Parts List Section 40A W-IF250 (4 x 4)-3.5M front axle I E'or Dana (SpIcer) hub I-z--I %Cl1'Z lA029-k

lA030 "0" RING - FREE RUNNING HUB KNOB W-IFI00/250 (4 x 4) I'F"-;0:-::rrD;-;;-an::-;a"(?<sp"'i-=-ce:-::rT')hcu:rb~-1'--9"/T<17>S"'f.D.-I11/1S"O.D.- j-rl CITZ IA030-A

1 1 rubber-also supplied in C1 TZ 1l04-A assy. ' : 1 I '11----

% Also SUpplIed m CITz lI04-A Assembly

14 SECTION 10 FORD TRUC#( PARTS

YEAR I MOD E L DESCRIPTION QTY. PART NUMBER

1042-3 CLAMP - SPOKE WHEEL RIM W--!B-C-F-CT-T70071106,-Nfr50JiTOO~ NT8507950-I-Front -~ -"- -------- ---- ilOor-2or-~-8-Q-- -1042--60/ :B-C-F600 (16M rear axle), N600 '850 i Front 10 61/ IH-HT850/1000 I Front i 12 61/ IB600 (8 cyl. 292 H/D & air brakes) ! Front ' 10 58/ I'C-F~N1100 -----~--~-- ·-·~-IRear-usewii:h 22.5"x!I.25",24-"--x7.5"&-S.25" 1121

60/62 1 C-F1000 ! wheels 1 12 !

8Q 1043-A

61/62 IH950/1000 I I 12 I I~j59-1~~~~;golmOO,(7T-'r75U/950---- ----~-I'ReI.._FstampeaWP-193 _. ------ -----~;~~201-~ B6Q 1043-A

58/ T700 (H/D axle) I : 20 I 60/ B-C-F600 (16M rear axle), N600/1000 I 10 i 61/62 C-F1100 ; 10 i 61/ IH-HT850/1000 ,NT850/950 II ilOor 20i 62/ ~-C-F600(15M rr. axle), B-C-F700(15" x 41/2" ,10 or 20!,

_~. brakes), T700(std. axle) "From Ser. 220,001" 1____ __. ____ ~ ___ .__ ___ __ __ ___ .J_

57/62' i-C-F700-With 15" x 4 1j2"rear brakes, T700 I Rear-stamped WP-142 IIoQr-2or-- B6Q 1043-B "Before Ser. 220, 001" I I

60/62 IB-C-F600(15Mrear axle)"Before Ser.220,001"I 10 58/ IC-F-NllOO I Rear-stamped WP-65-use with 20" &22··X'f.5"1~1 TUAA 1043-A 62/ !r850, HT850/950 i wheels 20 ,

63/ !cT-NT850/950, T950 1 120 1 57/ -IC-F-T900/950,C800/850 (with tube tires) 1 Rear-use with B8QH 1020-A rim,TUAA 1044-A j 10 or 20 !,

57/60 !F-T800/850 I spacer & 10"x20"-12plytires-stamped WP-166110or201

61 IF800/850 ! 10 i 62/ F-T800/850, CT950! r lOor20' 58/ C-F1000 Use with 20" & 22" x 7.5" wheels ! 10 ! 58/59 IC-FUOO ~ 10 I

61/ H950/1000 I /' 10 I 63/ 1N850/1000, NT850/950, CT750/850 1 10 or 20

D7Q 1043-A

-I-~-'-------- 1 1---1

57/ IB-C-CT-F-N-T700/1100,NT850/950 I Stud (front clamp to hub)-578"-1l & 5/8"-11 x 1'1"0---i-c1 3"'5""8"'67;;-'1--S;;;;8"'B;--~-61/ IH-HT850/1000 I 2 5/8" ilOor2Cl (WW62) 57/ IB-C-F700/1100,N700/950 i Stud (rear clamp to hub) 10 57/ 1 CT-T750/950 ! 20

63/ T700, NT850 I 20 61/62 IH950/1000 :. 10

I I Nut-5/S"-ll 1---13560S5-SS(MMT4)

57/62 T700 I Stud (rear clamp to hub T-97l6"-12&9/16"-12 x I 20 , 358708-S8B 57/62 iB-C-F700 (15" x4 1/2" rear brakes) I 2 1/8" '10 I (WW55)

=:l_:=~= ___ '_n~ ~_ ~~ - -- - II N"t~O/16"-12 i(R r'1::;;~7"lA"S)~~ 1044 SPACER - REAR SPOKE WHEEL RIM

~IB600/750;-C;- F::N6007rIOU; CT=N'r-T700/950 1"Z()"X4"=-usewith Quarwnee~---n-IAl.'tI- B7TZ 1044-C 61/ H-HT850/1000 I I AR , ~ C'I - '1'800;950, N 1'850 /950 -~~-~-1"'2mO'TT"-=xc-.3""-5;TC8m".-c_u~s=e~w=1=th~du""a""'I-;Cw;-;'[h:-:;e:-;;-e"'Is;--~-~-i-4t~7TZ 1044-A 57/ C900/950 I Use with tires with tubes I 2 I 57/ C-FSOO/ll00 [ I 2 ! 61/ H950/1000 2 62/ C'f750 I I 4 63/ IB-C-F-N700,N850/1100 I 1 2 57/ - IC~F-N900/1100' - -~~-- - --~-~I'22'-f~i1::iiSewTfh22"auarWheerS-- 2 --B7TZ 1044-13

58/ ICT-HT-NT-T900/950 I 4 61/ 1 H-HT850/1000 2 62/ ICT-NT-T850 I 4 -57j60---IC-F900liIOo - I 22"x 4~use with dual-whee1s - ---- --) i-58/60 IT950 I 62 IT950 (42DP & 42RP)

1070 SHIM - FREE RUNNING HUB CLUTCH 59/ I F100!250 (4 x 4j:::3Mfront -axle - ·-----1 For Warn huos.::r374·T(}.D.- f/o4"tulcK steel

I I

f Also supplied in COTZ l104-A assembly

4 4

2

B6TZT644-A

15 SECTION 10

YEAR 1 MODEL DESCRIPTION IQTY. i PART NUMBER 1080 LOCK RING - FREE RUNNING Hui INNER COUPLlM~'---==-=-=-=-~""':"":"':""':'~-----...!....:----'--------"":":"::"::;':----

W-- IFW()/250 (4 x4J-3M front axle ... -~--\~wa:rnnUDS-l 7/16" D.D. tCOTT I080-A

1088 WASHER - THRUST - FREE RUNNING HUB tCOTZ 108B-A Wr-I1"IOO/250 (4 x 4)-'3M front axle 1 For Warn hubs r-z-I

-~I-- --- 11--------------'1 1-----1089 CONTROL ASSY. - FREE RUNNING HUB

59T:-IFWOZ.z50J4x4)~3M {ront axfe---=--='-j FOfwarnhul5S-~-~'--- ----. --- -- i 'Z--I tCOTT WS9-A _JI_~ ___ -- -I~I ~----.--~----~----- -11---1

1 ___ _

1090-1 COUPLING - FREE RUNNING HUB fCOTT lO90-A

nn . 59/ (FI00/250 (4 x 4l-3M fron.t axle \ For Warn hubs-outer-48 splmes-2" 1.D.-3 178" I 2 I

~ FWO/250 (4 x 4J-:"3M front axle 1 For Warn hubs-mner-19 splmes on I.D.-20 1---Z--II~l"'C""O""'I"""I"'-' --tT1O"'9r<'1-_Ax-1 I grooves on O.D.

-~I-- ~ 1 --------1092 BEARING ASSY. - FREE RUNNING HUB INNER COUPLING

59 / I FlOO/250 (4 x 4l-3M front axle

1 -~I------------

I For Warn hubs-5/8" I.D.-2" a.D.-stamped B-2610

-------'1 1093 BODY - FREE RUNNING HUB CLUTCH

2 teOTT 1092-A

m-___ IF_l_O_O_12_5_0 _(~ "-4_r-_~f~ont ax.~le _____ ~I_F_.o_r_w_ar_n_h_u_b_S ________ ----I-r-__ t_CO_'I_'l_' _1O_9_3_-A_

:~1~100/250_~ x 4) s~:cer:t(~~Zct to coupling)-No. 10-32 x 1 1/4"- 116 371581-S2(UU8C)

=--=r--- ---­- I ---

_m_ ~ _n !'(jOTTIng-TI/8" I. D-:------- ~-·-2 -.- C1AZ 7 A294-A -- ----\"O"ring-l 7/8" 1. D. - . -- -----2-i-CIAZ'rC099=C

~-------. "a .. nng-2 5/8" I.D. -2-j87147-S91(T38) -~- ------1 . --------- -- --- ._---- : ----I

1094 PIN - FREE RUNNING HUB DRIVE 59T--I:l'iOO/250 (4 x 4l-3M fron"t -::cax"'l-:::e------t-II~F~o-ccr-.W"'a=r=n-.h~u~b-=s_-1r-ltT4~"~0~.D"'-._-Tl~9~."16~.~, ~Io-ng -~I----

109S PIN - FREE RUNNING HUB STOP

Ito! I 1

tCOT!' 1094-A

59/ rOOI25~J4 __ X_ 4~-JMTr'Oll~axle I For Warn hubs-lIS" a.D.-217M" long-kri~I--Y-I_t_C_O_'I_"I_' _1_0_95_-_A_

1097 KIT - SEAL and LOCK RING FREE RUNNING

~IF1007250 (4£ 4)-:HVlfront axle I Use with C4TZ H04-D 1 , Dana-Spicer free running hub Consists of 1-CITZ lA030-A 1-371834-S

"O'T Ring Lock ring

59/60 IFloQ7:f50 (4 x4)-3M front axle

I I

1-378391-S 1-378392-S

"OH Ring Lock ring

! Use with COTZ 1l04-A Warn I free running hub - consists of

1 3-"0" Rings 2-Lock rings i

or;--IF25U-\;rX~M front axle '~------I'~U~s-e-w~i"'th C1 TzlI04-A i Consists of 2-Cl TZ lA021-A Gasket

1-371834-S

I Dana-Spicer free running hub

1-87024-S91 "0" Ring Lock ring

1098 ACTUATOR - FREE RUNNING HUB CLUTCH 59/ i FIOO/250 (4 x 4)=31\ffront axle- - ~-IFor Warn hiios~I r/2·'IT.D~~I:.H.-square feeth -----r·----- u.. - - ---------1-----

1099 FLANGE - WHEEL RIM - Refer to 1007 Wheel Chart I I

1101 RING - FREE RUNNING HUB CLUTCH

I--Y-I I

B9'I'Z 109'/-A

I-Z--I B9TZ l097-B

: I

1 I

I- -Z--I en Z 109'/-A I ' I I

;2 i-olCOTT l098-A 1-1--

1

59/ IF100/250 (4 x 4)-3M front axle I For Warn hubs-20 grooves on I.D.-2 1/2" O.D.-I 2 COTT 1101-A !I 'i 8 grooves on O.D.-also supplied in

! COTZ 1104-A assy. ---1-------- ---------··-------'1 I-I 1102-3 KUB and BRAKE DRUM ASSY. - FRONT -Refer to Group 1104 I ------- - ---1-

t Also supplied in COTZ ll04-A Assembly

16 SECTION 11 FORD TRUC/( 'ARTS

YEAR I MOD E L DES C RIP T ION I QTY. I PART NUMBER

11 04 HUB ASS Y. _ FRO NT WHEEL - F R EEI'-:'-R_U_N_N.,--I N_G_----:-----:--c=cc_---:-;-_______ --.

59/ _\1 FIOO/250 (4 x 4) with 3M front ax~ Warn type-marked "Warn" I_~I COTZ 1104-A CITZ l104-A ~ FIOO/250 (4 x 4) with 3. 5M front axle I Dana (Spicer) type-marked "Hub Lok" tR I

1104 HUB ASSY. - FRONT - For Model Usage Refer to Application Chart on Page 18

FRONT HUB IDENTIFICATION CHART

INNER

CUP

SINGLE FLANGE DUAL FLANGE P·3657

FRONT HUBS for DISC WHEELS (For front hubs for spoke wheels, refer to Group 1109)

A B C D E F BEARING CUP PART NUMBER

PART NUMBER HOLES DRUM DRUM HOLES

SHOULDER INNER I OUTER LENGTH BOLT CIRCLE

No.1 DIAMETER NO. [ DIAMETER * STAMPED No.1 *STAMPED NO. BOLT CIRCLE DIAMETER

DUAL FLANGE

C3TZ 1104-H 11 1/4" 10

I TGAA 1202-A C3TZ 1202-A *45220 *25820

B7Y 1l04-B I 6 13/32" 7 1/4" 6 5/8" 71/4" 8 41/64" B7A 4222-A AA 1217-A *LM 501310 *1328

B7Q 1104-A 65/8" 8 3/4" ti ~D/3;l' (l' D 33/ti'!' 'lliAA 1~U;l-A 7EQ 1217

I *45220 *2720 B7T 1104-C 6 15/16" 8" 5 7/8' (I' 5 17/32' 9N 4222 7EQ 1217

*3720 *2720 C3TZ 1l04-G 6 15/16" 8" 5 7/8" 8" 5 117/ 32" 9N 4222 C3TZ 1202-A

*3720 *25820 B4Q 1104-A 6 15/16" 8 3/4' 0 7/8' 8' 5 17/32' ,9N 4222 7EQ 1217

*3720 *2720 B5Q 1104-A 6 15/10'

1

1U"

(I 7/8' 8' 5 17/32' 'lliAA 12U2-A 7EQ 1217 *45220 *2720

TUAA 1104-A 7 1/8" 11 1/4' 10 03/04' 8' 5 1/2' -13 7EQH 1239 81'1' 1202 *39520 *3525

B5QH 1104-C 7 1/4" 10" 8 i 7/8' IS' 5 17/32' 17EQH 1239 81T 1202 , I *39520 *3525

B5Q 1104-B 7 5/16" 10' (l 'I/(l' l(l' D 33/ti"!' I\!N 4222 7EQ 1217 *3720 *2720

B5QH 1104-A 7 1/2' , 11 1/"!' IV' os/o"!' (l' D 1'1 jJ;l' 'lliAA 1202-A 7EQ 1217 *45220 *2720

B9TZ 1104-A 8 1/"!' l! 1/4' lU ti3/ti'!' \!' D l'i /3~' 1::!9TT 12U2-A 19N 4222 *HM 212011 *3720

B5QH 1l04-B 8 5/16' 11 1/,,!' IV 03/0"!' \!' D 111 / S ;l' ;tlDl.,1tl l~U~-1::! 9N 4222 *553X *3720

B8QH 1l04-A 8 25/32' 8 7/32' lU 25/3~ IV D/tl' l iU U/3;l' Itl~1202-A B8QH 1217-A *6320 *532A

FDRD TRUC/( 'ARTS 17 SECTION 11

n04 HUB ASSY. - FRONT - continued FRONT HUB IDENTIFICATION CHART - For model usage refer to Application Chart on Page 18

A B C D E F BEARING CUP PART NUMBER

PART NUMBER HOLES DRUM DRUM HOLES SHOULDER INNER OUTER LENGTH BOLT CIRCLE

No.1 DIAMETER BOLT CIRCLE

NO., DIAMETER DIAMETER

* STAMPED NO. *STAMPED NO.

SINGLE FLANGE C3TZ 1104-D 6 83/4" TGAA 1202 -A I C3TZ 1202-A

*45220 *25820

C1TZ 1104-B 6 1/2" 8 B6J 1243-A B7A 4222-A * 362A *LM 501310

C2TZ 1104-A 11 1/4" 10 83/64" 9" 5 33/64" B9TT 1202-A 9N 4222

*B7C 1104-A 4 3/32" 5 1/2" 5 39/64' ---'~=-=-~~--'----f--......--c-=~-+-.-c"""'''''--!---''--+''''n=''--+-------lf----+-----+''''''-''''''~ 212011 * 3720

,35/32" IB7C 1202-A B5A 1217-A R/8 87TZ 11 02·A (2·68)

*B7D 1104-A 4 :5/:52' o 1/2' R/8 8HZ 11 02-8 (5.69)

B7J 1l04-A 4 29/64" 6 1/2'

B7Y 1104-A 4 29/64' 7 1/4'

*B9TT 1l04-A 6 3/8" 5 1/2' R/8 89TZ 1102·8 (5-69)

*B9TT 1104-B 63/8" tl 1/2' R/8 89TZ 1102·A

B7T 1104-B 6 3/8" 8"

C3TZ 1104-F 63/8" 8"

ts ;:nI/O'!'

II :59/tl4'

6 5/11'

5 39/64"

ts &J/t>'I'

5 '1Ill'

D 'I/!!"

i *LM 48510 *LM 11910

tl 1/2'

7 1/4'

:5 3/11' -16 !14 :5/4' 1 tHe I::lU::l-A *LM 48510

:5 :51!!' -10

:5 3/!!' -ltl

Jj'(A 4222-A *LM 501310

1 Jj7A 4222-A *LM 501310

:5 9/16' I 1:l7A 4::l2::l-B *LM 603011

o 1/2' ;j :57tF=-ro- 14 3/4' I B7A 4222-B 1 *LM 603011

lilA 121'I-A *09195 AA 1217-A *1328

IAA 1::l17-A *1328 B7A 4222-A *LM 501310 B7A 4222-A *LM 501310

I B 1202 <:> 1/2' Dolts' -I!! J 10/Hi' 1 JjOT 1202-A

*25522 *15250 01/2' D D/!!"-I!! iJ 15/16" B5A 1202-A C3TZ 1202-B

B7T 1104-A 6 9/16" !! :5/4' tl "I!!' 1- *LM 67010 *25520

-,~~~.--+~~~~~~-h~~~--hb~1~/'2~-+~ohD~/i~~_I~~~ b011202-A IB1202

" I' *25522 *15250 *25520 *LM 67010

C:5TZ 1l04-A 6 ID/16" II :514' 6 25/:52"

---_.- ---------- f--- --

! 6 15/16" 9N 4222

----1------j---+-----I-------. __ I--_____ ~---- *_3'1..~ ___ '~582~ ___ _

C3TZ 1202-A

---------1-----+-----I--+-----+----+--+-----=t=---+------+-------

---------1-----+-----I--+-----+----+--:I-----~~---~+__--+--------------------+------+-----+-+------1-----j----+---- _+ ____ +-____ --1--_____ _

-------+-.-------j------+--+-----f------+---- -----l-------+------j--------------.-!------+-------1---I----+------+---\----.----I..-- -------j---------

,

-------+-----+----+-+----+----+---,--------'--I--------j-------

-------+--------t-------+--+-----t-----+-+---·--t-i------t-!------- -------"--------------~------_+-------+--r_----~------_+--+_-----~------r---------\---------

---------- i--------I----+--+-----+----j----j-------1--- .. - - ------j-------------.. -------- - ,,-- -- ---- 1-------c---f-------+----+-- -- ------- ----- --- ------c-------

18 SECTION 11 FDID TIlUC/( 'AITS

1104 HUB ASSY. - FRONT - continued HOW TO UTILIZE FRONT HUB,DRUM .. RELATED PARTS CHARTS

1. Determine front axle capacity of the truck model for which the part is desired.

2. Select appropriate parts list number from Application Chart shown on pages 18 and 19

3. Refer to Parts List Chart (starting on page 20) for following items shown on adjacent pages:

1014 Hub assy. -front spoke wheel 1190 Retainer-front wheel grease

1104 Hub assy. -front disc wheel 1195 Washer-front hub outer bearing

1125 Drum-front brake 1202 Cup-front wheel inner bearing

1107 -8 Hub bolt 1217 Cup-front wheel outer bearing

1118-9 Hub bolt 1201 Cone & roller assy. -front wheel inner bearing

1012 Wheels nut 1216 Cone & roller assy. -front wheel outer bearing

1120-1 Wheel nut

4. For dimensions, identification numbers, etc., and for attaching parts, refer to appropriate groups listed in Section 11.

MODEL APPLICATION CHART FOR FRONT HUBS, DRUMS & RELATED PARTS

FRONT AXLE CAPACITY

This chart is to be used with the Parts Lists Chart on Pages 20 thru 23 For Rear Hubs. Drums. etc. refer to Page2'7 of this section

MOD E L BRAKE SIZE YEAR WHEEL VENDOR

1 SPOKE 11 DISC CODE@

2150 lb. I t;lUU 10 x 2.50 61/ 2600 lb., 2750 lb. F100 (4 x 2) 11 x 2 57/62 5

63 5

2600 lb. P100 11 x 2 57/62 5 63 5

.. -~~---~--

2600 lb. F250 (4 x 2) 12.12x2 57/63 8 3000 lb. FI00 (4 x 4) 11 x 2 59/ 5 3000 lb. F250 (4 x 4) 12.12 x 2 59/ 8 3500 lb. F250 (4 x 4) 12.12 x 2 61/ 8 3800 lb. IF 350-single rears 12.12x 2 57/ 6

F350-dual rears 12.12x2 57/ 6

P350-single rears-with 5200# rear axle 12.12x2 57/62 6 -with 5200# rear axle 57/ 8

P 350-dual rears 12.12 x 2 57/ 6

P400-single rears 12.12x2 57/ 6 P400-dual rears 12.12x2

57/ 6 4000 lb.,4700 lb. B-F-N-P500/600 13 x 2.25 57/62 5

63/ 5 57 6

14 x 2.50 58/62 6 5000 lb., 5500 lb. B-F-N500/750 14 x 2.50 63/ 20" D

63/ 5 K

63/ 6 B-D 6000 lb. B-F-N600/800,C500/600,T700 14 x 2.50 57/62 20"

63/ 20" G-K 57/62 5 63/ 5 57/62 6 63/ 6 D 57/62 8

16 x 2.50 57/62 20" 63/ 20" K 63/ 6 B 57/62 8

(ii) D-Dayfon --U"Gunl e K-Kelsey Hayes B-Buaa ~"R:ockwel1 t Size shown tt umber of studs shown * Parts Lists Start on Page 20

PARTS LIST

NO. *

1 3

141 3

141 9 5

13 14 15

18 19 20

22 23

26 27 28 29 30 32 33 34 35 36 37 38 39 40 41 46 47 48 49

FORD TRUCK 'ARTS SECTION 11 19

1104 - continued

MODEL APPLICATION CHART FOR FRONT HUBS DRUMS & RELATED PARTS , WHEEL VENDOR

PARTS FRONT AXL E CAP ACITY MOD E L BRAKE SIZE YEAR LIST

tSPOKE t1 DISC CODE@ NO.*

7000 lb. B-F-N700/950.C600/750. T700/750 16 x 2.25 & 57/62 20" G-K 55 16 x 2.50 63/ 20" D-G 56

57/62 22" G-K 57 63/ 22" G-K 58 57/62 6 59 63/ 6 B 60 57/62 8 G-K 61 57/62 10 G-K 62 63/ 10 B 63

9000 lb. C - F-700/ 1100 ,N750/ 1100, H950/ 1000, 15 x 3.0 & 63/ 20" 64 NT850/950,CT-T750/950 15 x 3.50 63/ 22" D 66

63/ 10 B 68

16x2.25& 57/ 20" G-D 71 16 x 2.50

57/ 22" G-D 72 57/62 8 G-D 73 57/ 10 B 74

1N·~x-:r:-w ~~/ :lV' G~D 75 57/ 22" G-D 76 57/ 10 B 77

11000 lb. C-F-N800/1100, HT850/950, H950/1000, 15 x 3.50 63 20" D 78 NT850/950, CT-T750/950 63 22" b SO

63 10 R 82 63/ 10 R 84

16 x 2.25 & 57/58 20" G-K 85 16 x 2.50 59/63 20" G-K 86

57/58 10 87 59/63 10 88 62/63 10 R 89

16 .25 x 3.50 57/58 20" G-K 90 59/63 20" G-K 91 57/63 22" G-K 93 57/58 10 95 59/63 10 96

62/ I 10 R 98

15000 lb. F-H-N1000/1100, C900/l100, HT950, 17. 25 x 3.50 57/

1

20

"

G-K 109 NT850/950 ,CT-T800/950 57/ 22" G-K 110

57/ 10 R 111

------ f---

@ D-Da ton Q! y G-Gunite K-Kelsey Hayes B-Budd R-Hockwell t Size shown tt N umber studs s hown * Parts Lists Start on Page 20

20 SECTION 11 FIJRD TRUC/( 'ARTS

1104 - continued

PARTS

LIST

NO.

1 I

3 4

5 9

13

14 15

18

19 20 22

23 26 27

28 29 30

32 33 , 34 !

35 36 37

38 39 40

41 46 47

I 48 49 55

56 57 58

59 60 61

PARTS LISTS CHART FOR FRONT HUBS,DRUMS & RELATED PARTS

(SEE INSTRUCTIONS FOR IDENTIFYING FRONT HUBS, DRUMS & RELATED PARTS ON Page 18 OF THIS SECTION) (CHART CONTINUED ON NEXT PAGE - SEE RELATED LINE NUMBER)

FRONT HUB FRONT DRUM HUB B 0 L T S HUB NUT S

(2 REQ'D.) (2 REQ'D.) R.H. (AS REQUIRED) L.H. (AS REQUIRED) R.H. (AS REQUIRED) I L.H. (AS REQUIRED)

C1UU 1l02-A % C1AZ 1107-A CIAZ 1107 -A B 1012 B 1012 B7TZ 1l02-A A8TZ 1125-A A9AZ 1107-A A9AZ 1107-A B 1012 B 1012 C6TZ 1102-B % A9AZ 1107-B A9AZ 1107-B B 1012 B 1012

'---

$B9TZ 1102-B COTZ 1125-A A9AZ 1107-B A9AZ 1107-B B 1012 B 1012 B7TZ 1102-B C3TZ 1125-C 8D l107-A 8D 1107 -A B 1012 B 1012

$B9TZ 1102-A % ~J.J llV'I-A ~J.J llU7-A B 1012 B 1012

pern:. llV4-jj elT£; 1l02-A ~J.J llU'I-A ~J.J llV'l-A tl 1012 tl 1012 jj'lX llV4-A C3TZ 1l2t>-L jjDY ll07-A jjD Y 11 V'{-A B7TZ 1120-A B7TZ 112v-A

B7Y 1104-B C3TZ 1125-C TCAA 1107 -A TCAA 1108-A B'ITZ 1120-A B7TZ 1121-A

B7Y 1104-A C3TZ 1125-L B5Y l107-A B5Y l107-A B7TZ 1120-A B7TZ 1120-A B7J 1104-A C3TZ 1125-C 8D 1107-A 8D l107-A B 1012 B 1012 B7Y 1104-B C3TZ 1125-C TCAA 1107-A TCAA 1108-A B7TZ 1120-A B7TZ 1121-A

B7Y 1104-A C3TZ 1125-L B5Y 1107-A B5Y 1107-A B7TZ 1120-A B7TZ 1120-A

B7Y 1104-B C3TZ 1125-C TCAA 1107 -A TCAA 1108-A B7TZ 1120-A B7TZ 1121-A B7T 1104-B B5T 1125-A 51 1107 51 1108 BB 1120 BB 1121

C3TZ 1104-F B5T 1125-A 51 1107 51 1108 BB 1120 BB 1121 B7T 1104-A B4T 1125-A 51 1107 51 1108 BB 1120 BB 1121 B7T 1104-A B7T 1125-B 51 1107 51 1108 BB 1120 BB 1121

C3T£; 1014-E B7Q TI25-A Ll Ll Ll Ll

C3TZ 1104-F C4TZ 1125-L 51 1107 51 1108 BB 1120 BB 1121

C3TZ 1104-B C3TZ 1125-M #C4TZ 1107 -C #C4TZ 1107-D {I BB 1120 {I BB 1121

B6Q 1014-A B7Q 1125-A Ll Ll Ll Ll

C3TZ 1014-A B7Q 1125-A Ll Ll Ll Ll

B7T 1104-C B8T 1125-A 51 1107 51 1108 BB 1120 BB 1121

C3TZ 1104-G B8T 1125-A 51 1107 51 1108 BB 1120 BB 1121

B4Q 1104-A B8T IT25-A 51 1107 51 1108 813 TTIO- BB 1121

C3TZ 1104-A C3TZ 1125-A {ltA'n:. llU7-C #C4T£; 1l07-V # 13B 1120 {I BB 1121

135Q 1104-B BST 1125-A 7EQ 1118 7EQ 1119 BB 1120 BB 1121

B6Q 1014-A B7Q 1125-C Ll Ll Ll Ll

C3TZ 1014-A B7Q 1125-C Ll Ll Ll ~

C3TZ 1104-A C3TZ 1125-E {lC4TZ 11v7-C ilC4TZ l107-D # BB 1120 41 BB 1121

B5Q 1104-A B7Q 1125-B 7EQ 1118 7EQ 1119 BB 1120 BB 1121

B6Q 1014-B B7Q 1125-C Ll Ll Ll Ll

C3TZ 1014-C , B'7Q 1125-C Ll Ll Ll ~

COTT 1014-A B7Q 1125-C Ll Ll Ll ~

C3TZ 1014-B B7Q 1125-C Ll Ll Ll Ll --1--------------

B7Q 1104-A B7Q 1125-B 7EQ 1118 7EQ 1119 BB 1120 BB 1121

C3TZ 1104-D C3TZ 1125-E &C4TZ !lV'I-E &C4TZ llv7-F &BB 1120 &BB 1121

B5QH 1104-C B7Q T125-B 7EQ 1118 7EQ 1119 BB IT20- BB 1121

$ Use in conjunction with COTZ 1104-A (59 63)-Warn !j. Use in conjunction with C1 TZ 1104-A for free running hubs % Part of 1102 Hub & Drum Assy_ $ For ball seat mounted wheels - use C3TZ 1118-B (R. H. & L. H.) and C3TZ 1120-A (R. H. & L. H.) fa: pilot mounted wheels & For ball seat mounted wheels - use C3TZ 1118-F (R. H. & L. H.) and C3TZ 1120-A (R. H. & L. H.) for pilot mounted wheels Ll Use 358671-88B rim stud & 356085-88 rim nut and 370114-88 drum bolt & 33846-88 drum nut

FORD TRUC/( 'ARTS 21 SECTION 11

1104 - continued

PARTS LISTS CHART FOR FRONT HUBS,DRUMS & RELATED PARTS

(SEE INSTRUCTIONS FOR IDENTIFYING FRONT HUBS, DRUMS & RELATED PARTS ON Page 18 OF THIS SECTION) (CHART CONTINUED FROM LAST PAGE - SEE RELATED LINE NUMBER)

PARTS RETAINER WASHER BEARING cUP S BEARINGS LIST (2 REQ'D,) (2 R EQ'D,) NO, INNER (2 REQUIRED)I_ OUTER (2 REQUIRED) INNER (2 REQUIRED) OUTER (2 REQUIRED)

-r-- -c1tJZ fHlO-A --

C2AZ-n95~A - --:s5A 1:r02---A-- ----f:l5K-T2T1=A:--- ---B5AI2or:'A ---- ---- -:B--sA-l~fB-A --

3 137C 1190-A C2AZ 1195-A B7C 1202-A B5A 1217-A B7C 1201-A I B5A 1216-A - - "-

4 c5'rz1190-A ---

- C2AZ- I Ef5--A- ---B7C-mZ':A--- ---B1>:A-1217-=-A -- ---E\'fc 1201':A- I ---

1216-1\ B5A

t----Brr4222-A --- 4221 ~B---+-B7A-422T:A---5-- -B9TZ -1'190-=11:--- I B7A 4222-B B7A

9 B7C 1190-A C2AZ 1195-A B7C 1202-A 135A 1217-A B7C 1201-A 135A 1:l16-A 13 B9TZ 119U-A

.1 B7A 4222-B B-,A 4222-A B7A 4221-13 , B7A 4221-A

I 14 CITZ 1190-A B6J 1243-A B7A 4222-A CITZ 1201-A B7A 4221-A

15 B7TZ 1190-A 13 1195 137A 4222-A AA 1217-A B7A 4221-A

I AA 1216-A

18 B7TZ 1190-A 13 1195 137A 4:l22-A AA 1:l17-A 137A 4221-A AA 1216-A I

19 B7TZ 1190-A 13 1195 137A 4:l22-A I AA 1:l17-A 137A 4221-A AA 1216-A

20 137TZ 1190-A 13 1195 137A 4222-A AA 1217 -A 137A 4221-A I AA 1216-A

22 B7TZ 1190-A 13 1195 B7A 4222-A AA 1217-A 137A 4221-A AA 1216-A ----c--- !

I

23 B7TZ 1190-A 13 1195 B7A 4222-A I AA 1217-A 137A 4221-A I AA 1216-A

26 137TZ 1190-A 13 1195 137A 4222-A ! AA 1217-A 137A 4221-A I AA 1216-A

27 B7T 1190-A B7J 1195-A B6T 1202-A 13 1202 137T 1201-A I 91T 1216 --- -- -----

i I --28 137T 1190-A C3TZ 1195-A C3TZ 1202-13 I 135A 1202-A B7T 1201-A I 135A 1201-A

29 137T 1190-A B7J 1195-A B6T 1202-A 13 1202 B7T 1201-A I 91T 1216 30 137T 1190-A

I 137J 1195-A 136T 1202-A i 13 1202 B7T 1201-A ! 91T 1216

I I -- --~ -------f-

32 137T 1190-A C3TZ 1195-A C3TZ 1202-13 B5A 1202-A 137T 1201-A 135A 1201-A 33 137T 119U-A I C3T:,'; 1195-A C3TZ 12U2-B 135A 12U2-A 137T 12Ul-A 135A 1201-A

34 B7T 1190-A C3TZ 1195-A C3TZ 1202-13 B5A 12U2-A 1371' 120l-A i B5A 1201-A ---- I

35 !C3TZ 1l90-A tnT 1l~5-A iJN 4:l:l:l "EQ 121'1 "EQ 1201 I 7EQ 1216

36 C3TZ 1190-A 137T 1195-A 9N 4222 C3TZ 1202-A 7EQ 1201 C3TZ 1216-B 37 .lC3TZ 119U-A 117'1' 1195-A 9N 4222 7EQ 1217 7EQ 1201

I 7EQ 1216

----i

38 C3TZ 1190-A I B7T 1195-A 9N 4222 I C3TZ 1202-A 72:Q 1201 I C3TZ 1216-8 39 ,C3TZ 1190-A B7T 1195-A 9N 4222 I 7EQ 1217 7EQ 1201 7EQ 1216 40 C3TZ 1190-A B7T 1195-A 9N 4222 C3TZ 1202-A 7EQ 1201 C3TZ 1216-B

41 AC3TZ 1190-A 137T 1195-A 9N 4222 7EQ 1217 7EQ 1201 7EQ 1216 46 AC3TZ 1190-A B7T 1195-A 9N 4222 7EQ 1217 7EQ 1201 , 7EQ 1216 47 C3TZ 1190-A I 137T 1195-A 9N 4222 C3TZ 1202-A 7EQ 1201 i C3TZ 1216-B ~-- -----

j

48 C3TZ 1190-A I B7T 1195-A 9N 4222 C3TZ 1202-A 7EQ 1201 C3TZ 1216-B 49 AC3TZ 1190-A I 137T 1195-A TGAA 1202-A 7EQ 1217 7EQ 1201 I 7EQ 1216 55 C3TZ 1190-C TGAA 1195-A TGAA 1202-A 7EQ 1217 TGAA 1201-A TGAA 1216-A

---- I

I 56 C3TZ 1190-C

, TGAA 1195-A TGAA 1202-A C3TZ 1202-A TGAA 1201-A I C3TZ 1216-A

57 C3TZ 1190-C i

TGAA 1195-A TGAA 1202-A 7EQ 1217 TGAA 1201-A i

TGAA 1216-A 58 C3TZ 1190-C I TGAA 1195-A TGAA 1202-A C3TZ 1202-A TGAA 1201-A C3TZ 1216-A

---~-i~--

59 C3TZ 1190-C TGAA 1195-A TGAA 1202-A 7EQ 1217 TGAA 1201-A TGAA 1216-A 60-f--c3~1190-C -.--

I TGAA 1195-A TGAA 1202-A C3TZ 1202-A - TGAA 1201-A C3TZ 1216-A 61 C3TZ 1190-C I TGAA 1195-A 7EQH 1239 81T 1202 TGAA 1201-A TGAA 1216 A --r----

I • Use A8TZ 1190 A for 1957/60 -

22 SECTION 11 FORD TRUC/( 'ARTS

1104 - continued ---------------------------------------------------------------------------------PARTS LISTS CHART FOR FRONT HUBS,DRUMS & RELATED PARTS

(SEE INSTRUCTIONS FOR IDENTIFYING FRONT HUBS, DRUMS & RELATED PARTS ON Page 18 OF THIS SECTION) (CHART CONTINUED ON NEXT PAGE - SEE RELATED LINE NUMBER)

PARTS FRONT HUB FRONT DRUM HUB B 0 L T S HUB NUT S LIST (2REQ'D) (2 REQ'D,) NO, R,H, (AS REQUIRED) L,H, (AS REQUIRED) R,H, (AS REQUIRED) L,H, (AS REQUIRED)

62 B5QH 11u4-A B7Q 1125-B 7EQ 1118 7EQ 1119 BB 1120 1313 1121 63 C3TZ 1104-H B7Q 1125 -13 7EQ 1118 7EQ 1119 BB 1120

~ BB 1121

\)4 B'/I,JH lUl"!-A C:lTZ 1l:<5-H t. t. t. I t. i I

66 i B7QH 1014-B C3TZ 1125-H t. t. t. I A

68 TUAA 1104-A C3TZ 1125-J:<' 7t:Q _Illl '[t:Q 1119 tltl ll~U I tltl 1121 71 I B7QH l014-A 1 B7Q 1125-c t. t. t. _, ____ A_

--- - --~---------- ---- ---------~----------~---f-- -- -----

I I

'/:< J:}'/Iq!H J.Ul'f-J:} J:}IIq! 1125-C t. t. t. A

73 tl5QH 11U4-C tl'[Q 1125-tl 7t:Q 1118 7EQ 1119 BB 1120 i BB 1121 74 TUAA 1104-A ___ B'[~ I~b-~_ '(t:Q 11Itl '(t:Q !llll_ tltl l1:<U _l-___ tltl_ll~~_

--- ---. - ----------- ---- ------------ ---- -------- ----

75 B7QH 1014-A tlllQH 112b-A t. t. t. t.

76 B7QH 1014-13 B8QH ll~b-A t. t. t. A

77 TUAA 1104-A I BIlQH ll:<b-C '(~I,J 1118 ___ ~Q __ l~~_ Btl 1l~0 : BB 1121 ----- ----------- -i---~---------------------- -- ---T---~-

- - -------

78 C7TZ 1014-G I C3TZ 1125-H t. t. t. A

79 C4TZ 1014-E C4TZ 1125-H t. t. t. A

80 B9TT 1014-V I C:l'l'Z l1~b-H t. t. t. A ---- -----------1----------- r--------------- -_ .. _-- ------- ------ ------!--- ------ -----,

82 B9TZ 1104-A I C3TZ 1125-G 7EQ 1118 7EQ 1119 BB 1120 I BB 1121 84 "C2TZ 1104-A I C3TZ 1125-G C2TZ 1107-A c2'l'Z l107-B CITT 1120-A ! C1TT 1121-A 85 * B7QH lU14-c

+ B'/I,J 1125-C t. t.

t. ------L---~--------

86 C7TZ 1014-G I37Q 1125-C t. t. t. ! t.

87 B5QH 1104-B B5QH 1125-A 7EQ 1118 7EQ 1119 BB 1120 ,BB 1121 88 B9TZ 1104- A B5QH 1125-A 7EQ 1118 7EQ 1119 BB 1120 += BB 1121 ---t---------~----t__-------1--- -------- r----- -- -~-----, --- ------ -----

89 "C2TZ 1104-A B5QH 1125-A C2TZ ll07-A C2'l'Z 1107-B clTT 1120-A C1TT 1121-A 90 *B7QH 10I4-C B8QH 1125-A t. t. t. t.

~ C7TZ 1014-G i B8QH 1125-A t. t. t. t. I-----~-- -----

93 B9TT 1014-D I B8QH 112b-A t. t. t. t.

95 B5QH 1104-B i B8QH 1125-B 7EQ 1118 7EQ 1119 BB 1120 BB 1121

96 B9TZ 1104-A B8QH 1125-13 7EQ 1118 '(EQ 1119 BB 1120 BB 1121 ____ --t.. ___ ------__ ----~- - 1- r-------- ---- ------1------ -------

98 "C2TZ 1104-A B8QH l1~b-tl C:<TZ ll07-A C2TZ 1l07-tl CITT ll:<U-A C1TT 1121-A

109 B8QH 1014-A B8QH 1125-E t. t. t. A

110 B8QH 1014-B +--B8QH 1125-E t. t. t. A ---------

111 B8QH 1104-A i BSQH 1125-D B8QH 1107-A B8QH 1108-A BB 1120 BB 1121 I

141 B7TZ 1102-A Yo A9AZ 1107-B A9AZ 1107-B B 1012 B 1012 --------- --- ------

---~ -~----------

!

I

------ ----------+----------- 1--------- -- ---- ----------------- ---

-

i

I I -I

... Aluminum % Part of Hub and Drum Assy • * Use C7TZ lOH-A for 191 Il

t. Use 358671-88B rim stud & 356085-88 rim nut and 370114-88 drum bolt & 33846-88 drum nut

FORD TRllc/( IIARTS 23 SECTION 11

1104 - continued

PARTS

LIST NO.

62 63 64

66 68 71

72 73 74

75 76 TI

78 79 80

82 :B4

85

86 87 88

89 90 91

93 95 96

98 109 110

111 141

*

PARTS LISTS CHART FOR FRONT HUBS,DRUMS & RELATED PARTS

(SEE INSTRUCTIONS FOR IDENTIFYING FRONT HUBS. DRUMS & REU TED PARTS ON Page 18 OF THIS SECTION) (CHART CONTINUED FROM LAST PAGE - SEE RELATED LINE NUMBER)

RET AIN ER WASH ER BEARING CUP S BEARINGS

(2 REQ'D.) (2 REQ'D.) INNER (2 REQUIRED) OUTER (2 REQUIRED) INNER (2 REQUIRED) OUTER (2 REQUI RED)

C3TZ 1190-C TGAA 1195-A TGAA 1202-A 7EQ 1217 TGAA 1201-A TGAA 1216-A -- --------~

c3'fz-----r216-A -C3TZ 1190-C TGAA 1195-A TGAA 1202-A C3TZ 1202-A TGAA 1201-A B5QH 1190-A 8EB 1195 7EQH 1239 81T 1202 8Q 1201-A 8EB 1216

BEQH 1190-A 8EB 1195 7EQH 1239 81T 1202 8Q 1201-A 8EB 1216 B5QH 1190-A 8Elj 11\J5 7EQH 12:19 BIT 1202 tlQ 12U1-A tlj;;lj 1216

I35QH 1190-A 8EB 1195 7EQH 1239 81T 1202 8Q 1201-A 8EB 1216

B5QH 1190-A 8Elj 119::> 7EQtl 12:J9 8IT 1202 8Q 1201-A 8EB 1216 B5QH 1190-A 8Etl 1195 7EQH 1239 81T 1202 BQ 1201-A 8EB 1216

B5QH 1190-A 8EB 1195 7EQH 1239 Bl T 12U2 _~ lZUI-A 8EB 1216

m·QH 1190-A 8EB 1195 7EQH 1239 81T 1202 8Q 1201-A 8EB 1216

B5QH 1190-A 8EB 1195 7EQH 1239 81T 1202 8Q 1201-A 8EB 1216 BtlQH 1190-A HEB 119!:> 7EQH 1239 81T 1202 8Q 1201-A 8EB 1216

B;)QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B5QH 1216-A 'C4TZ 1190-A C4TZ 1195-A B3QH 124:l-A ll9TT 1202-A C4TZ 1201-A C4TZ 1216-A

B5QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B5QH 1216-A

B5QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B5QH 1216-A B5QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B5QH 1216-A B5QH 1190-A 8EB 1195 B5QH 1202-B 9N 4222 B5QH 1201-A B5QH 1216-A

B5QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B5QH 1216-A B5QH 1190-A 8EB 1195 B5QH 1202-B 9N 4222 B5QH 1201-A B5QH 1216-A B5QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B;;QH 1216-A

B5QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B5QH 1216-A B5QH 119U-A 8Ell llgo B5QH 1202-B 9N 4222 B5QH 12~I-A B5QH 1216-A B5QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B5QH 1216-A

B5QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B5QH 1216-A B5QH 1190-A 8EB 1195 B5QH 1202-B 9N 4222 B5QH 1201-A B:;QH 1216-A B5QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B5QH 1216-A

B5QH 1190-A 8EB 1195 B9TT 1202-A 9N 4222 B9TT 1201-A B5QH 1216-A B8QI-i 1190-A B8QH 1195-A B8QH 1202-A B8QH 1217-A B8QH 1201-A B8QH 1216-A UtlQtl 119U-A UtlQti 119!)-A tl!lf.!ti 12U2-A tltllo,!ti 121'{-A Utllo,!tl 12U1-A tltlQtl 12Hi-A

B8QH 1190-A BHQI-i 1190-A BHQI-i 120z-A BHQH 1217-A BBQI-i 120l-A BHQI-i 121o-A B7C 1190-A C2AZ 1195-A B7C 1202-A B5A 1217-A B7C 1201-A B5A 1216-A

Use C4TZ 1195-B as washer

24 SECTION 11 FORD TRUC/( 'ARTS

1107-8 BOLT - HUB

S I Z E

1/2"-20 x 1 15/32"

1/2"-20 xl 1/2"

1/2"-20 x 1 5/8"

1/2"-20 x 1 3/4"

1/2"-20 x 1 27/32"

5/8"-18 x 1 3/4"

5/8"-18 x 2 1/8"

5/8"-18 x 2 1/8"

1109 HUB ASSY. - REAR

STAMPED NUMBER

D680

W985

V1114

R 20-58 A

R 20-59 A

R 20-60 A

R 20-65 A

R 22-65 A

R8596

For model usage refer to charts under Basic Groups 1104 & 1109

PART NUMBER S I Z E PART NUMBER

C1AZ ll07-A 3/4"-J6 x 2 1/4" 51 1107 R.R.

A9AZ 1107-A 3/4"-16 x 2 1/4" 51 n08 L.R.

A9AZ 1l07-B 3/4"-16 x 2 3/8" C4TZ 1107-C R.R. .~~----

8D 1107-A 3/4"-16 x 2 31'8" --f---. C4TZ _lJ07-D _ . L.II_._

C6TZ 1107-A 3/4"-16 x 2 5/8" C4TZ 1107-.E ___ . R.R. _.-

B5Y 1107-A 3/4"-16 x 2 5/8" C4TZ 1107-F L.R.

TCAA 1107-A R.R. 3/4"-16 x 3 1/8" C2TZ 1107-A R.R.

TCAA 1108-A L.R. 3/4"-16 x 3 1/8" C2TZ l107-B L.R.

3/4"-16 x 3 1/8" B8QR l107-A R.R.

3/4"-16 x 3 1/8" B8QR 1108-A L.R.

.. -_ ..

REAR HUB STAMPING NUMBER CROSS-REFERENCE FOR MODEL USAGE REFER TO PAGE 27

ALSO SEE IDENTIFICATION CHART ON PAGE 25

PART NUMBER STAMPED NUMBER PART NUMBER

C1TZ 1109-A _ R_8tHJU C;:T£ 11U\I-1) _. - ----- .- .. - --- -- - -- _ .. ~ ------

C1TT 1109-A R 20-149 E B8QIf 1109-B ---- -------f-.- .- --- ----~--~

C2TZ 1109-A R 22-101 B C;,rn:. 11U\I-1:3 ---- ------- - .. _- .. - .. _- --- . -

B6Q 1109-B R 22-149 D B8QR 1109-C ----------- -_. -------- _. -- -------_.-

B6Q 1109-A E 54037 *C4TZ 1109-A Replaced bv C4TZ 1l09-B

B6QR 1l09-A 85111 C3T£;_ 1109-1:1

B7QR 1109-A -- ----- - - - --------- .- --- - .. . -

86432 C3TZ 1109-B 1:1'110/1:1 11U\I-B

90063 .. C'ITL. 1_1U9-B . C3TZ 1109-E

._-._---------

1109 - contInued

PART NUMBER

B10 1109-A -----~ ----

B4J 1109-A

C3TZ 1109-G ._-- -. __ ... ---

TEAA 1109-B

C5TZ 1109-T

C1TT 1109-A

CITZ 1109-A

C4TZ 1109-B ---~-------- ------_.

COTT 1109-A

B5Q 1109-A

B30H 1109-A

C5TZ 1l09-L

C5TZ 1109-M

7EOH 1109-B

B50H 1l09-A

C:5TZ 1109-N

B80H 1109-A

--- .--.-~- ... _--

OUTER BEARING

CUP

A

I Length

I 5 63/64" r--'

5 63/64"

_6_7j}6". __

7"

7"

7 5/16"

7 13/32"

2.Ji.16"

7 29/64"

7 1/2"

8 13/16"

8 13/16"

8 13/16"

9 5/8"

9 5/8"

95/8"

10 3/4"

-- - . __ .-----

SECTION 11 25

RIAR HUll for DIIC WHIILI

D c

INNER

CUP

SINGLE FLANGE DUAL FLANGE P.3658

HUB IDENTIFICATION CHART B C D BEARING CUPS

Bolt Circle BOLT HOLES BOLT HOLES INNER OUTER

No. Diameter No. Diameter Part Number Stamped No. Part Number ~tamped No.

6 1/2" 8 39/64" 3 3/8"-16 910 1243 18720 91D 1243 18720 .--_.

6 1/2" 8 39/64" 3 3/8"-16 B6J 1243-A 362-A i 61 1239 354-A !

7 1/4" 6 5/8" ~~;\~~2~}-A 382-A I B6J 1243-A 362-A --- ---------"- -: .--- ----- ---T---·-"- .- ------

I

8" 5 25/32" 3 1/2"-13 B6T 1243-A 3920 BB 1239-A 453-X

83/4" 6 25/32" B6T 1243-A 3920 BB 1239-A 453-X

11 1/4" 10 25/32" B8QH 4222-D' 653 'B9TT 1202-A , HM 212011

! 11 1/4" 10 31/32" 5 1/2"-13 B60 1243-A 493 I B6T 1243-A 3920

i 8 3/4" 6 25/32" B4Q 1243-A ~4.~L_ _t-~§..'!:. __ 1_2i~-.A_ 3920

.------~--

83/4" 6 25/32" 3 1/2"-13 B4Q 1243-A 33462 i B6T 1243-A 3920

10" 8 25/32" 4 1/2"-13 B6Q 1243-A 493 B6T 1243-A 3920

11 1/4" 10 25/32" rrUAA 1243-A 592-A ,TUAA 1239-A 572 .~---

I 11 1/4 10 20/32 ITUAA I243-A 592-A ,TlJAA 1239-A 572

,

11 1/4" 10 982 TUAA 1243-A 592-A TUAA I239-A 572 i

10" 8 25/32" 4 1/2"-13 EQH 1243 47620 17EQH 1239 39520

11 1/4" 10 25/32" 5 1/2"-13 EQH 1243 47620 ffEQH 1239 39520 ,

11 1/4" 10 25/32" EQH 1243 47620 17EQH 1239 39520

1 11 1/4" 10 25/32" 1B8QH 1243-A 752 B8QH 1239-A 742

I

_. __ . __ . -- j.-_. _ .. _-----f-.----- ----- ._- ----------- ---.---

26 SECTION 11

1109 - continued

S A P

PART NUMBER 0 K DI AM HER E S

B6Q 1014-A 5 19 3/S B6Q 1014-B 5 19 3/8'

B7QH 1014-A 5 1\l 3/1l'

B7QH 1014-B 5 21 3/S"

B7QH 1014-C 5 HJy~ B9TT 1u14-D 5 z1 3/ll'

*C7TZ 1014-G 5 193/S" COTT 1014- A 5 21 ~3Lll' C3TZ 1014-A 5

C3TZ 1014-B 5 21 3/S" C3TZ 1014-C 5 19 3/S" C3TZ 1014-E 5 IS 9/16'

C4TZ 1014-E 5 19 3/S" BSQH 1014-A 6 19 ~/S' BSQH 1014-B 6 ::11 ~/ll~_, --_.-.- _.- - .----. ---

H6Q llU9-A 5 18 _35/6'1'

B6Q 1109-B 5 Hl35/tl'1'

B6QH 1109-A 5 19 3/S" B7QH 1109-A 5 IS 35/64" B7QH 1109-B 5 20 1/2" C2TZ 1109-D 5 IS 35/64" C3T:.'; 1109-E 5 18 9/10 BSQH 1109-B 6 IS 35/64' BSQH 1109-C 6 20 1/2"

*TUAA 1109-D 6 20 1/2" r;bB3TZ 1113-B&D

FDRD TRUC#( 'ARTS

FRONT and REAR HUB - SPOKE TYPE For front hubs for disc wheels refer to Group 1104

FRONT REAR

HUB IDENTIFICATION CHART

B C D

P·3659

BEA~IN

INN E R

LENGTH RIM WI DTH BOLT CIRCLE

PART NUMBER I STAMPED NO.

FRONT HUB - SPOKE TYPE 5 l/Z' 11' \IN '1::1::1::1 ~nu

5 3/8' 11' TliAA 12U::I-A 'I5::i::lU

o \l/16' 11' '{~~tl 123\l 3\l:>::IU

6 9/16" 11' 7~~tl 1Z3\l J\l5ZU

tl 10/32' 11 J:jO~tl 12U2-J:j OO;5-A

o 1/2' 11' J:j\j 11 12U2-1\ tiNI 212U11

6 15/32" II" B9TT 1202-A HM 212011 o 3/ll' 11' 1\.71\1\ 12U2-1\ '1022U

\IN '1Z::I::I 3'{2U

5 3/S" 11 TGAA 1202-A 145220 5 3/S" 11" TGAA 1202-A 45220

5 3/16" 20 xS 11 C3TZ 1202-B 25520

6 23/32" II" BSQH 1243-A 752 8' 22"x7.5" 11' J:jll~tl 12U2-1\ 0;52U

tI' 11' .~~~~._I~U2-1\ Oil2U --- - - ---- -~ .- -------_. ---------- -~-.--

REAR HUB - SPOKE TYPE 105/052' o 05/'1' 12 1/~' J:jO~ 12'1.>-1\ '1\j;j

'{ Z\l Itl'I , tl 31'1' lZ liZ' J:j'l~ 12'13--" ""'10~

9 5/8' 6 3/4" 12 liZ' 7~QH 1243 4762U

S 13/16" 6 3/4" 12 1/2' TUA1\ 12'1il-A 0;1::1-1\

S 13;16" 63/4' 12 l/Z' TUAA 1243-A 592-A

7 29/64" 63/4" 12 1/2" B4Q 1243-A 33462 \j'lllO' tl ;l/ltl' U 1/::1' 7~~tl 12'13 '1762U 1u 31'1' '{3/32' lZ liZ' H8QH 1243-A 752 103/'1' '{ 3/3::1' lZ liZ' H8~tl 1243-A 752 S 13/1tl' '{ 3/3Z' lZ liZ' TUAA 1243-A 592-A

* Usea tor !"ront Wheel :,;peectomMer Drive

G CUP S

OUT E R

PART NUMBER lSTAMPED NO.

H;~ lZ1'{ Z'I2U 'l~~ 1217 2720 !lIT l::1UZ 3:>::1:> !lIT 12U2 3525

9N 4222 372U 9N 42Z2 372U

9N 4222 3720 7EQ 1217 272U

C3TZ 1202-A 25S20 C3TZ 1202-A' 25S20 C3TZ 1202-A 25S20

B5A 1202-A 67010

B9TT 1202-A HM212011 J:jtl~tl 1217-A 532-A

.J.j~~tl __ l::1 !.~!: 532-A ----- -------

J:jtlT l::1'10-A 3\lZU J:j01 12'10-1\ ;j\j2U

7EQH 123\l 3\l52U TUAA lZ31J-1\ 572 TUAA 12;5IJ-A 572

B6T 1243-A 3920 7~QH 1Z39 39520 B8QH l::1;5\l-A 742 B8QH l::1;5\l-A '(42 TUAA l::1;j\l-A 572

SECTION 11 n09 - continued

HOW TO UTILIZE REAR HUI,DRUM .. RELATED PARTS CHARTS 1. Determine rear axle capacity of the truck model for which the part is desired.

2. Select appropriate parts list number from Application Chart shown on pages27 thru 29

3. Refer to Parts List Chart (starting on page 30) for the following items shown on adjacent pages:

1109 1126 1107-8 1118-9 1124 1174

Hub assy. -rear Drum-rear brake Hub bolt Hub bolt Washer-rear wheel bearing nut lock Wiper assy. -rear axle shaft

1175 1181 1243 1239 1244 1240

Retainer-rear wheel grease Oil seal assy. -rear axle Cup-rear wheel inner bearing Cup-rear wheel outer bearing Cone & roller assy. -rear wheel inner bearing Cone & roller assy. -rear wheel outer bearing

4. For dimensions, identification numbers, etc., and for attaching parts, refer to appropriate groups listed in Section 11.

MODEL APPLICATION CHART FOR REAR HUBS, DRUMS & RELATED PARTS TIDS CHART IS TO BE USED WITH THE PARTS LIS'J CHART ON PAGES 30 THRU 33

FOR FRONT HUBS, DRUMS, ETC. REFER TO PAGE 18 OF THIS SECTION

27

WHEEL VENDOR PARTS REAR AXLE CAPACITY MOD E L BRAKE SIZE YEAR

CODE @ LIST

tSPOKE i ,DISC NO.·

2300 lb. E100 10 x 1. 75 61/ 5 1

2700 lb. , 3050 lb. EI00 10 x 2.50 63/ 5 2

3300 lb .• 3600 lb. FI00 (4 x 2) 11 x 1. 75 57/ 5 3

FI00 (4 x 4) 11 x 1. 75 59 5 4 60/ 5 5

P100 11 xl. 75 60/ 5 6

5000 lb. , 5200 lb. F250 (4 x 2) 12.12 x 2.0 57/ 8 7 !

F250 (4 x 4) 12.12 x 2.0 59 8 9 60/ 8 10

P350 12.12x2.0 57/ 8 11

7200 lb., 7400 lb. F350 13 x 2.50 57/62 6 12 63/ 6 14

P350/400 13 x 2.50 57/62 6 15 13 x 2.50 63/ 6 17

llUUU lb. P500 14.125 x 3.50 57/ 5 18

11000 lb., 13000 lb. B-F-N500,C500/550 15 x 4.0 57/ 5 , 19

@ lJ-lJayton G-uumte K-Kelsey Hayes B-l:!UClCl H-Hockwell t Size shown Number f * Parts List start on Page 30

tt o studs shown

28 SleTION 11 FtlRD TRU~I( 'ARTI

1109 • contInued

MODEL APPLICATION CHART FOR REAR HUBS, DRUMS & RELATED PARTS

REAR AXLE CAPACITY

15000 Ib.(22000 lb.-Tandem)

16M, 17M,17:5M-;-281r& 30M Ibs.

18000 lb. (dead axle)

I

WHEEL VENDOR

MOD E L BRAKE SIZE YEAR

'ISPOK~i 1 DISC CODE @

C-F-N500/600 ,B500/700, T700 15 x 4.0 57.62 ~ 63/ 20" I D-G 57/62 6 63/

I 6 D

15 x 4. tlU tl'I/02 2U" i 63/ 20" I

F6007S06,B-c,,",OO!7W;--- ---- 15 xs:o---;" -26,,-1 ~ -- :-HT850/950,NT850,CT-T700/850 57/62 8

63/ 6 B

16.50 x 4.50

NT85U, HT85U/95U 15 x 0. U

61/ 110 R

57/ 20" 57/62 8

63/ 6 B 61/ 10 R

1 03/

63/

u

R

- - ._-

PARTS

LI ST

NO:

I 21 22 23 24

26 27 28 29

---s"C 34 35 36

42 45 46 47

49 50

10. 5U x 0. U ;:IV" u 51 10 R 52

18000 Ib:-,I85001~,34000 lb. -B-C-F-N700)850, F-N950-D, ._- --_._.-- "1"5--x"6C";.0-----T6"'3"/--- :::--Y-ir, 20" +-l~-~-_----t~~

(exc.SLDD & Shear ride H-Nl000-D,HT850/950,NT850,T800/850, 63/ suspension CT800/950 63/

63T---

63/ 63/

22" I D 64 10 R I 67

21M,22M,23M & 38M lbs. (except SQDD or SQHD)

'I C-F-N800/1000, HT850/950, NT850/950,CT-T950

I ! I

i I I I

For 16. 50x 5.50 see 34000 lb.

16 x 5.0

16.50 x 0. U

16 x 6.<X38M only}

15x 7.0

57/ 20" 62/ 22" 57/62 57/

;n/ou 2U"

61/ 20" I 57/62 8 57/ 10 R

o;j/ 2U" G-K 63/ I 22" I ! G-K 63/ I i 10 IR 63/ I 20" I G-K 63/ I 22" G-K 63/ 10 R 63/ 10

@! u-uayton u-uunite K-Kelsey Hayes l:!-l:!uctct H-Rockwell T ::size shown tt Number of studs shown * Parts List start on Page 30

1 I

69 179 70 71

72 73

I

76 77

! 82 85

i

! 88

I 91 I 94 1 97

I 99

FDRD TRUC/( 'ARTS 29 SECTION 11

1109 - continued

MODEL APPLICATION CHART FOR REAR HUBS. DRUMS & RELATED PARTS

WHEEL V EN DOR I PARTS REAR AXLE CAPAQTY MOD E L BRAKE SIZE YEAR LIST

It SPOKE ttDISC CODE @ I NO. * 21M, 22M, 23M & 38M lbs. C-F-N800/ 1000, HT850/950, Hi x ti.~l!IM, o7/olS 2U" 10i-(except SQDD or SQHD) NT850/950,CT-T950 22M only)

59 20" G-K 168 60/ 20" 102 57/58 22" 104 59 22" G-K 171 60/ 22" 105 57/ 10 107

I 62/ 10 109

16.50x ti.U(21M. :H/511 2U' ti-K llU 22M. 38M only) 59 20" G-K 170

60/ 20" G-K 111

57/58 22" 114 59 22" G-K 169

16.50 x 6.0 60/ 22" G-K 115 57/59 10 118 60/ 10 B 119 62/ 10 R 121

21M, 22M, 23M & 38M lbs. C - F-N800/ 1000, HT850/950 16.50 x 7.0 57/ 20" G 123 57/ 22" G 127 57/ 10 131 62/ 10 133

For 22000 lb. Tandem axlE see 15000 lb.

For 28uOu lb. see ltiUUU lb.

and 17000 lb.

29000 lb. C-F-Nl000/1100 16.50 x 7.0 57; 20" 135 57/ 22" 136 57/ 10 137

For 30000 lb. see 16000 lb. & 17000 lb.

For 34000 lb. (exc. SLDD & Shear ride suspension)-see 18000 lb. & 18500 lb.

34000 lb. & SLDD T800/850, CT800/850, HT850/950, NT850 16.50 x 5.50 57/ 20" G-K 138 63/ 22" G-K 139 57/62 8 I 140

I 57/ 10 i 141

38000 lb. (SQDD or DQHD) T950 16.50 x 6.0 57/ 20" ! G-K 144 57/ 22" I G-K 145 57/ 10 B 146

42000 lb.,44000 lb. T950 16.50 x 7.0 ~2/; 20" i G-K 147 22"

, G-K 148

62/ 10 B 149 50M,55M,60M,65M lbs.- T950 16.50 x 7.0 62/ 20" G-K 150 (SUDD & SFDD) 62/ 22" G-K 151

62/ 10 R 152

@ V-Vayton li-liuni e K-Kelsey Hayes B-Budd R-Rockwell t Size shown tt Number of studs shown * Parts List start on Page 30

30 SECTION 11 FORD TRUC/( 'ARTS

1109 - cont'~in~u~e~d~-----------------------------------------------------------------------------

PARTS

LIST

NO.

1 2 3 4 5 6 7 9

10

11 12 14 15 17 18 19

21 22 23 24 26

--2Y 28 ~9

31 34 35 36

42 45 46 47 49

50 51 52 53 56 59 61 67 69

70 71 72 73

76 77 --- --

82 85 88

PARTS LISTS CHART FOR REAR HUBS,DRUMS & RELATED PARTS

(SEE INSTRUCTIONS FOR IDENTIFYING REAR HUBS, DRUMS & RELATED PARTS ON PAGE 27 OF THIS SECTION) (CHART CONTINUED ON NEXT PAGE - SEE RELATED LINE NUMBER)

HUB B 0 L T S REAR HUB REAR DRUM WASHER VI I PER (2 REQUIR ED) (2 REQUI RED)

R. H. (AS REQ'D.) L. H. (AS REQ'D.) (2 REQUIRED) (2 REQUI RED)

CWU 1126-A C1AZ 1107-A C1AZ 1107 -A C30Z 1126-A C1AZ 1107-A C1AZ 1107-A C4TZ 1126-A A9AZ 11U7-B A9AZ 1107-B C4TZ 1126-A A9AZ 1107-B A9AZ 1107-B C4TZ 1126-A A9AZ 1107-B A9AZ 1107 -B C4TZ 1126-A C1AZ 1107-A C1AZ 1107-A

BlD 1109-A B6D 112t5-A 8D 1107-A 8D 1107-A 61 1124 BID 1109-A B6D 112t5-A 3D l107-A 8D 11u7-A 61 1124 BlD 1109-A COTT 1126-A 8D 1107 -A 8D 1107 -A 61 1124

-

B4J 1109-A B6D 1126-A 8D 11u7-A 8D 1107 -A 61 1124 C3TZ 1109-G C2TZ 1126-D B9TT 1118-A B9TT 1119-A B6Y 1124-A C3TZ 1109-G C2TZ 1126-D BOTT 1118-A B9TT 1119-A B6Y 1124-A C3TZ 1109-G C2TZ 1126-D B9TT 1118-A B9TT 1119-A B6Y 1124-A C3TZ 1109-G C2TZ 1126-D BliTT 1118-A B9TT 1119-A B6Y 1124-A I TEAA 1109-B TDAA 1126-A TDAA 1118-A TDAA 1119-A 01T 1124 I TEAA 1109-B TEAA 1126-A TDAA 1118-A TDAA 1119-A 01T 1124

B6Q 1109-B Bf.Q 1126-C B4T 1124-A B6Q 1174-A C2TZ 1109-D B6Q 1126-C 358688-88 358688-88 B4T 1124-A B6Q 1174-A COTT 1109-A B9TT 1126-B TDAA 1118-A TDAA 1119-A B4T 1124-A , B6Q 1174-A C4TZ 1109-B C4TZ 1126-C ~ C4TZ 1107-E #C4TZ 1107-F B4T 1124-A B6Q 1174-A

B6Q 1109-B B7Q 1126-A 358708-8 358708-8 B4T 1124-A B6Q 1174-A C2TZ H09-D- --. -tl7Q--U26-A- -358688-88------ - -35-8688~S8 --- --1341' -H24~A --'B6Q 1174=-A---COTT 1109-A B7Q 1126-B TDAA 1118-A TDAA 1119-A B4T 1124-A B6Q 1174-A C4TZ 1109-B C4TZ 1126-B ~ C4TZ 1107 -E # C4TZ 1107-F B4T 1124-A B6Q 1174-A

B6Q 1109-A B6Q 1126-A 7EQ 1124 7EQ 1174 B5Q 1109-A 8Q 1126-A 7EQ 1118 7EQ 1119 7EQ 1124 7EQ 1174

C3TZ 1109-B C3TZ 1126-E Ii C4TZ !lU'i-E IiC4TZ 11u7 -F 7EQ 1124 7EQ 1174 C1TZ 1109-A C1TZ 1126-A CITZ 1118-A ~1119-A 7EQ 1124 7EQ 1174

B6Q 1109-A B6Q 1126-D 358703-88 358703-88 7EQ 1124 7EQ 1174 B5Q 1109-A B6Q 1126-B B6Q 1118-A B£Q 1119-A 7EQ 1124 7EQ 1174

C3TZ 1109-B C3TZ 1126-F II C4TZ 1107-E II C4TL; 11u7-F 7EQ 1124 7EQ 1174 C1TZ 1109-A C1TZ 1126-B C1TZ 1118-A C1TZ 1119-A 7EQ 1124 7EQ 1174

C3TZ 1126-N C1TT 1124-A

C1TT 1109-A C3TZ 1126-L 7EQH 1118 7EQH 1119 C1TT 1124-A C1TT 1126-B C1TT 1124-A

C1TT 1109-A C1TT 1126-C 7EQH 1118 7EQH 1119 C1TT 1124-A C3TZ 1109-E C3TZ 1126-M 358703-88 358703-88 7EQH 1124 B7TZ 1174-A B6QH 1109-A C3TZ 1126-M 8Q 1151 8Q 1151 7EQH 1124 B7TZ 1174-A B5QH 1109-A C3TZ 1126-J 7EQH 1118 7EQH 1119 7EQH 1124 B7TZ 1174-A C3TZ 1109-E C3TZ 1126-R 358703-88 358703-88 7EQH 1124 B7TZ 1174-A B5QH 1109-A C3TZ 1126-G 7EQH 1118 7EQH 1119 7EQH 1124 B7TZ 1174-A B6QH 1i09-A B6QH 1126-G 7EQH 1124 B7TZ 1174-A

7EQH 1109-B 7EQH 1126 7EQH 1118 7EQH 1119 7EQH 1124 B7TZ 1174-A B5QH 1109-A B5QH 1126-B 7EQH 1118 7EQH 1119 7EQH 1124 B7TZ 1174-A B6QH 1109-A B,;"TZ 1126-A 7EQH 1124 B'?TZ 1174-A B6QH 1109-A COTT 1126-C 358703-88 358703-88 7EQH 1124 B7TZ 1174-A

7EQH 1109-B B7QH 1126-C 7EQH 1118 7EQH 1119 7EQH 1124 B7TZ 1174-A B5QH 1109-A B7QH 1126-D 7EQH 1118 7EQH 1119 7EQH 1124 B7TZ 1174-A -- .. _----_ .... __ ... -f-.- ... ----.----.- +--------------- ---------- --- --------- -----

B7QH 1109-A C3TZ 1126-8 358703-88 358703-88 TUAA 1124-A B7QH 1109-B C3TZ 1126-8 358703-88 358703-88 TUAA 1124-A B3QH 1109-A C3TZ 1126-H 7EQH 1118 7EQH 1119 TUAA 1124-A

l! For baH seat mounted wheels - use CJT~ 1118-A (R. H. & L. H.) and C3TZ 1120-A (R. H. & L. H.) for pilot mounted wheels

FDRD TRUC/{ 'ARTS 31 SECTION 11

1109 - continued

PARTS

LIST

PARTS LISTS CHART FOR REAR HUBS, DRUMS & RELATED PARTS (SEE INSTRUCTIONS FOR IDENTIFYING REAR HUBS, DRUMS & RELATED PARTS ON PAGE 27 OF THIS SECTION)

(CHART CONTINUED FROM PREVIOUS PAGE - SEE RELATED LINE NUMBER)

B EAR I NG CUPS BEARINGS RETAINER OIL SEAL 1 1

NO. lZ REQ'D.l (2 REQ'D.) INNER (2 REQ'D.l OUTE~~ REQ'D~ __ ~.~~~(2 __ RE~~~=~_~_~EQ'D')_

~~i==t~=----~=.=-=-.· •. ·----·~·---C-6-T--Z-1-1S--l-_A--r-.--------.---;-~---· . -------i~!}~t~~~=1-- r---·_-_·-_-_-._-_

4 C9AZ 1225 A - 5-- ----- ----- -C6TZ l1s1-"A - -+----.. ---.--.- ---·-----j--C .. 9'"'AZ-1225~-~A--·-+--- -.~-

6 7 9

10

11 12 14 15 17

-Is 19

-21

22 23 24

.-

26 -27--

28 29

31 34 35

ASTZ 1175-B 91D 1243 91D 1243 B6D 1244-A 8D 1240 A8TZ 1175-B 91D 1243 91D 1243 B6D 1244-A SD 1240 A8TZ 1175-B 91D 1243 91D 1243 B6D 1244-,-A=-=-_t---=8=D---=1:..::2c.::.40.:........._

B4J 1175-A B6J 1243-A 61 1239 B6J 1244-A 61 1240 B2TZ 1175-A TCAA 1243-A B6J 1243-A TCAA 1244-A B6J 1244-A B2TZ 1175-A TCAA 1243-A B6J 1243-A TCAA 1244-A B6J 1244-A B2TZ 1175-A TCAA 1243-A B6J 1243-A TCAA 1244-A B6J 1244-A B2TZ 1175-A

-- -- --- --- ----B6J ff75~X - - TCAA 1243:~ B6J 1243-A ~CAA -11224-144_-BA --~B6BJ -11224404-_~-AA----B6T 1243'::A -- BB T239-A-- 13ST

B6J 1175-A B6T 1243-A BB 1239-A B6T 1244-B BB 1240-A

B6Q 1175-A BST 1181-A B4Q 1243-A B6T 1243-A & B6T 1240-A B6Q-rr75:'A -:I36T118f--X-- B4Q 1243-=-T--- I--Biff ·T24S~··- -- --- ,- -----.-- -B6T-124Q:.T-

B6Q 1175-A B6T 1181-A B4Q 1243-A B6T 1243-A , B6T 1240-A B6Q 1175-':'A --136T118i-=-1\- """""B4Q1243"=-x-·-·-B6T--i2,fs::X---- - -.- ,------- -13ST -1240=-£-

--.. - .. ----.----.-- .--.--.----.-- -.--.. --- --.. -- --1--- -.--. -- .. - .. - .. - -- ---.. -.- ----

7EQ 1175-A B9T 1181-A B6Q 1243-A B6T 1243-A 7EQ 1244 B6T 1244-B 7EQ 1175-A B9T 1181-A

-7E-Q-f175:A - - --B9T-nsT:'A-- B6T 1244-B ---- -"-_ .. --_._---

BST 1244-B _36_-+-._7_E .. Q~~.11750 __ B9T 1181-A B6Q 1243-A B6T 1243-A 7EQ 1244 B6T 1244-B

42 7EQ 1175-A B9T 1181-A B6Q 1243-A B6T 1243-A 7EQ 1244 B6T 1244-B 45 7EQ 1175-A B9T 1181-A B6Q 1243-A B6T 1243-A 7EQ 1244 B6T 1244-B

-46--- 7EQ-li75~A-- --1391' -fISl--':'"A---I--B6Q1243.::A -r-B6T-l243::X-- -mQ-1244--- -B6Tl244=Il 47 7EQ 1175-A B9T 1181-A B6Q 1243-A B6T 1243-A 7EQ 1244 B6T 1244-B 49 C1TT 1175-A C1TT 1183-A B8QH 4222-D B9TT 1202-A C1TT 1244-A C1TT 1240-A

50 C1TT 1175-A C1TT 1183-A B8QH 4222-D B9TT 1202-A C1TT 1244-A C1TT 1240-A 51 C1TT 1175-A C1TT 1183-A B8QH 4222-D B9TT 1202-A C1TT 1244-A C1TT 1240-A 52 C1TT 1175-A C1TT 1183-A B.3QH 4222-D B9TT 1202-A C1TT 1244-A C1TT 1240-A 53 7EQH 1175 8QH 1181 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240 56 7EQH 1175 8QH 1181 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240

59 7EQH ~1,1~75~--_+I-c8~Q~H,-~1~18~1---+"7~E~Q~H,,1~2~4~3---~~7E~Q~H~1~23~9~-~~7~E~Q~HT_~12~4~4--_+~7~E~Q~H~1~2~4~0---61 7EQH 1175 . 8QH 1181 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240 67 7EQH 11~75~---~~'-n.8Q~H;,-'1~18~1---+~7~E~Q~H~1U2~4~3----+~7~E~Q~H~1~2n.39~--~7~E~Q~H~~12~4~4---+~7~E~Q~H~1~2~470---~ ....JEQH 1175 ~.8=-Q"'H:.:......::.1c:c18:..:1:..........---+--'7c::E::..:Q;.:::H"--1:..::2:..:4..::.3---+..."7=E.::oQ!{ 1239 7EQH 1244 7EQH 1240

70 7EQH 1175 8QH 1181 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240 71 7EQH 1175 8QH 1181 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240 72 7EQH 1175 8QH 1181 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240

____ 76'----+--7-E....:Q'-H.:.........1-,1'-=7..::..5----~----.::.8-"Q.H 1181 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240 ~ 7EQH 1175 8QH 1181 7EQH 1243 7EQH ' 239 7EQH 1244 7EQH 1240

73 7EQH 1175 8QH 1181 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240

82 85 88

TUAA 1175-A __ fTUAA 1181-A TUAA 1243-A TUAA 1175-A TUAA 1181-A TUAA 1243-A TUAA 1175-A-- TUAA 1181-A TUAA 1243-A

.. - .--- --- .-.----1---.- ... ----.- -.- ...

, Use B6T 1244-C with 15M axles and B6T 1244-A with 22M axle

TUAA 1239-A TUAA 1239-A TUAA 1239-A

TUAA 1244-A TUAA 1244-A TUAA 1244-A

TUAA 1240-A TUAA 1240-A TUAA 1240-A

32 FtJRD TRUCI( flARTS SECTION 11 1109 - continued

PARTS

LIST

NO.

91 94 97 99

101 102 104 105 107 109 110 111 114 115 118 119 121 123 127 131 135 136 137 138 139 140 141 144 145 146 147 148 149 150 151 152 168 169 170 171 179

PARTS LISTS CHART FOR REAR HUBS, DRUMS & RELATED PARTS (SEE INSTRUCTIONS FOR IDENTIFYING REAR HUBS, DRUMS & RELATED PARTS ON PAGE 27 OF THIS SECTION)

(CHAR', CONTINUED ON NEXT PAGE - SEE RELATED LINE NUMBER)

REAR HUB REAR DRUM HUB B 0 L T S

WASHER WI PER

(2 REQUIRED) (2 REQUIRED) R. H. (AS REQ'D.) L. H. (AS REQ'D.l (2 REQUIREDl (2 REQUIRED)

137QH 1109-A C3TZ 1126-R &

137QH 11 09-13 C3TZ 1126-R &

133QH 1l09-A C3TZ 1126-G 7EQH 1118 7EQH 1119 &

'C2TZ 1l09-A C3TZ 1126-K %C2TZ 1118-A %C2TZ 1119-A &

133TZ H13-A 137QH 1126-A &

137QH 1109-A 137QH 1126-A C5TZ 1151-A C5TZ 1151-A &

133TZ 1113-D 137QH 1126-A &

137QH 1109-13 B7QH 1126-A C5TZ 1151-A C5TZ 1151-A &

133QH 1109-A TUAA 1126-13 TUAA lll8-A TUAA 1U9-A &

'C2TZ 1109-A C2TZ 1126-13 %C2TZ 1118-A %C2TZ 1119-A &

133TZ 1113-C B7QH 1126-13 &

B7QH 1109-A B8QH 1126-E 358671-8 358671-8 &

133TZ 1113-13 B7QH 1126-B &

137QH 1109-B B8QH 1126-E 358703-58 358703-5S & 133QH 1l09-A B5QH 1126-C TUAA 1118-A TUAA 1119-A & B3QH 1109-A B8QH 1126-F TUAA 111S-A TUAA 1119-A &

'C2TZ 1109-A C2TZ 1126-C %C2TZ 1118-A %C2TZ 1119-A & 137QH 1109-A 138QH 1126-C 358703-58 35S703-5S & 137QH 1109-13 BSQH 1126-C 358703-5S 35S703-5S & B3QH 1l09-A B8QH 1126-13 TUAA l11S-A TUAA 1119-A & 138QH 1109-13 BSQH 1126-D 35S703-8S 35S703-SS 138QH 1124-B B9TZ 1174-B B8QH 1109-C B3QH 1126-D 35S703-8S 358703-8S 13SQH 1124-B 139TZ 1174-B 138QH 1109-A BSQH 1126-A B8QH 1US-A 138QH 1119-A 13SQH 1124-13 B9TZ 1174-B 136QH 1109-A B6QH 1126-F 35S671-8 358671-8 7EQH 1124 137TZ 1174-A C2TZ 1109-13 136QH 1126-D SQ 1151 8Q 1151 7EQH 1124 B7TZ 1174-A 7EQH 1109-B 136QH 1126-13 7EQH 111S 7EQH 1119 7EQH 1124 B7TZ 1174-A 135QH 1109-A 136QH 1126-E 7EQH 1118 7EQH 1119 7EQH 1124 B7TZ 1174-A 137QH 1109-A B8QH 1126-E 35S671-8 35S671-8 TUAA 1124-A B'lQH 1109-B 13aQH 1126-E 358671-S 358671-S TUAA 1124-A 133QH 1109-A 13SQH 1126-F TUAA 1118-A TUAA 1119-A TUAA 1124-A 137QH llUII-A 138QH 1126-C 35S671-S 35S671-S 138QH 1124-A 137QH 1109-13 B8QH 1126-A C5TZ 1151-A C5TZ 1151-A BSQH 1124-A B3QH 1109-A B8QH 1126-B TUAA 1118-A TUAA 1119-A B8QH 1124-A 138QH 1109-13 138QH 1126-D SQ 1151 8Q 1151 138QH 1124-13 BSQH 1174-A 13SQH 1109-C B8QH 1126-D SQ 1151 SQ 1151 B8QH 1124-13 D8QH 1174-A 13SQH 1109-A B8QH 1126-A 7EQH 1118 7EQH 1119 13aQH 1124-B BSQH 1174-A 133TZ 1113-A 137QH 1126-A & 133TZ 1113-13 B7QH 1126-13 & B3TZ 1113-C B7QH 1126-B & 133TZ 1113-D 137QH 1126-A & C2TZ 1113-13 136QH 1126-G 7EQH 1124 137TZ 1174-.1'.

YEAR I MODEL 1 DESCRIPTION IQTY.I PART NUMBER

57r---IB-C-F-N700/S50,T750/S50 ----I Nut-l/2"-20 -------'1 AR I 33846-S8(M69) I LOckwasher-i/2" I AR 1 34S09-S8(X68)

m-\T700---------·---~ 8tud (axle shaft to hub)-7/16"-14 & 7/16"-20 x 1 32 1 358704-S(WW45)

II I 2 3/16"-with 15" x 4" & 4 1/2 brakes 116 I

1 Nut-7/ 16"-20 I AR 1'-3=5C71=02=5-c_8=7C=(M7CM~2~3~) ---"-I ARJ 34S08-88(X67) Lockwasher-7j16" -I ~135S671-S&'13(WW62;

AR 1"6085-88(MM14) AR 370114-SS(1313250)

Stud(clamp to hub)-5/S"-11&5/S"-lix2 5/S" Nut-57S"-1l

I Bo1t(drum to hub)-1!2"-20 x 1 3/4" Nut-1!2"-20 hex_

-\ I & Use TOAA 1124-A with 22M & 38M axles and BeQH l124-A with 23M axle % Use in conjunction with C2TZ 111S-13 (stUd) for aluminum hubs * Aluminum

AR 33S46-SS(M69) I

I I

33 'DRD TRUC#( 'ARTS SECTION 11 1109 - continued

PARTS LISTS CHART FOR REAR HUBS, DRUMS & RELATED PARTS (SEE INSTRUCTIONS FOR IDENTIFYING REAR HUBS, DRUMS & RELATED PARTS ON PAGE 27 OF THIS SECTION)

(CHART CONTINUED FROM PREVIOUS PAGE - SEE RELATED LINE NUMBER)

PARTS RETAIN ER OIL SEAL BEARIN G CUP S B EAR I N G.5

LIST (2 REQ'D.) (2 REQ'D.)

NO. INNER (2 REQ'DJ OUTER (2 REQ'D.) INNER (2 REQ'D') OUTER (2 REQ'D.)

91 I J * TUAA 1243-A TUAA 1239-A t -t

94 :) * TUAA 1243-A TUAA 1239-A t t 97 r; * TUAA 1243-A TUAA 1239-A t t 99 (> * TUAA 1243-A TUAA 1239-A t t

101 0 * TUAA 1243-A TUAA 1239-A t t 102 ,) * TUAA 1243-A TUAA 1239-A t t 104 (> * TUAA 1243-A TUAA 1239-A t t 105 C * TUAA 1243-A TUAA 1239-A t t 107 (> * TUAA 1243-A TUAA 1239-A t t 109 ) * TUAA 1243-A TUAA 1239-A t t 110 0 * TUAA 1243-A TUAA 1239-A t t 111 (> * TUAA 1243-A TUAA 1239-A t t 114 ,) * TUAA 1243-A TUAA 1239-A t t 115 ) * TUAA 1243-A TUAA 1239-A t t 118 0 * TUAA 1243-A TUAA 1239-A t t 119 (> * TUAA 1243-A TUAA 1239-A t t 121 (> * TUAA 1243-A TUAA 1239-A t t 123 (> * TUAA 1243-A TUAA 1239-A t t 127 0 * TUAA 1243-A TUAA 1239-A t t 131 (> * TUAA 1243-A TUAA 1239-A t t 135 B8QH 1175-B B8QH l1S1-B BSQH 1243-A B8QH 1239-A BSQH 1244-B BSQH 1240-A 136 BSQH 1175-B BSQH 1181-B BSQH 124::1-A tltllo,lH 12::1!:1-A tltllo,lH 1244-tl tl8QH 1240-A

137 BSQH 1175-B BSQH l1S1-B BSQH 1243-A BSQH 1239-A BSQH 1244-B BSQH 1240-A

13S 7EQH 1175 SQH l1S1 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240 139 7EQH 1175 SQH 11S1 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240 140 7EQH 1175 SQH 11S1 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240 141 7EQH 1175 SQH 11S1 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240 144 TUAA 1175-A TUAA l1S1-A TUAA 1243-A TUAA 1239-A TUAA 1244-A TUAA 1240-A

145 TUAA 1175-A TUAA l1S1-A TUAA 1243-A TUAA 1239-A TUAA 1244-A TUAA 1240-A 146 TUAA 1175-A TUAA l1S1-A TUAA 1243-A TUAA 1239-A TUAA 1244-A TUAA 1240-A 147 B8QH 1175-A B8QH l1S1-A TUAA 1243-A TUAA 1239-A ~ B8QH 1240-B 14S BSQH 1175-A BSQH l1S1-A TUAA 1243-A TUAA 1239-A ~ B8QH 1240~B

149 BSQH 1175-A BSQH 1181-A TUM 1243-A TUAA 1239-A .. B8QH 1240-B 150 BSQH 1175-B BSQH 11S1-B BSQH 1243-A BSQH 1239-A B8QH 1244-B BSQH 1240-A 151 BSQH 1175-B BSQH 11S1-B BSQH 1243-A B8QH 1239-A BSQH 1244-B BSQH 1240-A 152 BSQH 1175-B BSQH 11S1-B BSQH 1243-A BSQH 1239-A BSQH 1244-B BSQH 1240-A 16S (> * TUAA 1243-A TUAA 1239-A t t 169 " * TUAA 1243-A TUAA 1239-A t t '. 170 t * TUAA 1243-A TUAA 1239-A t t 171 ~ * TUAA 1243-A TUAA 1239-A t t 179 7EQH 1175 BSQH 11S1 7EQH 1243 7EQH 1239 7EQH 1244 7EQH 1240

YEAR MODEL DESCRIPTION QTY. PART NUMBER orr- C-F900/1100,H950/1000 StUd (axle shilft to hub)-3/4"-10 & 3/4"-16 x I~i 352480-AS(WW69) 5S/ 1 T950,HT850/950 33/4" 32 --I Nut-3/4"-16 [--I 34675-S8(M75) ---I LOckwasher-3~- -- --------- -----------/34853-S7(X77)

W-IC-F1100 (with spoke wheels) Stud-5/S"-11 & 5/S"-IS x 2 15/16" -~ 370723-S(WW65) ~I C-F1100 (with disc wheels) Stu -5/S"-11 & 5/S"-lS x 2 3/4" 16 I 37064S-S(WW63) ==1 1 Nut-5/S"-18 1--1 33850-S8(M72)

Lockwasher-5/S" 34811-S2(X71) 57/ --I --- -- --------rStud-578'~TI&578'·-::.1TX2578"-------- i--1-35S671-S8B(WW62)

63/ F350, P350/400 I Pin (wheel pilot)-5/16" x 1 1/~"-_________ J._.2._ 72292-S8(N76_) _ ----:------------------- [ Nut-11/16"-5/8" i AR I 356085-S8(MM14) -~I I II

I) Use TUAA 1175-A with 22M & 38M axles & B8QH 1175-A with 23M axle t Use TUAA 1181-A with 22M & 38M axles & B8QH 1181-A with 23M axle t Use TUAA 1244-A (inner) & TUAA 1240-A (outer) with 22M & 38M axles and B8QH 1244-A (inner) &

BSQH 1240-B (outer) with 23M axle J. Use BSQH 1244-A with Timken axles and C2TZ 1244-A with Eaton axles

ILLUSTRATIONS

1957 1963-FORD TRUCK

PARTS ANDACCESSORIES

CATALOG

GENERAL INFORMATIONMODEL IDENTIFICATION

QUICK REFERENCE INDEX PAGE

SECTION - MISCELLANEOUSINSTRUMENT PANEL& RELATED PARTS

SECTIONS 10-26WHEELS, BRAKES

SECTIONS 30-35FRONT AXLE, STEERING

SECTIONS 40-42REAR AXLE

SECTIONS 46DRIVE SHAFTCOUPLING SHAFT

SECTIONS 60-60ENGINE

SECTIONS 70-75MANUAL TRANSMISSION, CLUTCH

SECTIONS 80-85COOLING, GRILLE

SECTIONS A70-A76AUTOMATIC TRANSMISSION

SECTIONS T70-T75TRANSMATICTRANSMISSION

SECTIONS 90-97FUEL, CARBURETOR, ACCELERATOR

SECTIONS 100-120GENERATOR, ALTERNATORSTARTER, DISTRIBUTOR

SECTIONS 130-145LAMPS, WIRING

SECTIONS 160-166FENDER, HOOD

SECTIONS 174-197AIR CONDITIONING,HEATER, SHOCK ABSORBER,WINDSHIELD WIPERS AND WASHERS

BODY SECTIONS - DOOR AND WINDOWSSEAT, SHEET METAL, EXTERIORMOULDING, INTERIOR TRIM

COPYRIGHT 1970 - FORD MOTOR COMPANY DEARBORN, MICHIGAN1970FORM AF 7698

II

12

179

228

271

280

346

-

403

512

529

© .

AutoliteAUTOLITE - FORD PARTS DIVISION

SECTIONS 50-55FRAME, EXHAUST SYSTEM, SUSPENSION

884

832

561

611

719

773

818

1

II GlENERAL INFCIRMATION

F'RD TRIJCK PIIRTS

MAS,TER PARTS AND ACCESSORIES ILLUSTRATION CATALOG

FORM AF-7698

AUTO LITE- FORD PARTS DIVISION

GENER,AL INSTRUCTIONS

This Ford Truck Master Parts Catalog contains parts illustrations for Ford Trucks for Model Years 1957 through 1963.

For greater convenience this catalog is divided into specific sections, 'I1ch as brakes, front axle, engine, transmission, etc. For example, FRONT AXLE appears in Section 30, REAR AXLE in Section 40, CARBURETORS in Section 95, etc.

A separate catalog which contains the text or descriptive infonnation for the same model years i,s available as Form AF-7697. The "Text" catalog is divided into sections also and like parts are shown under sitailar section numbers in both the "Text" and "illustration" Catalogs.

A listing of Ford baSic or group numbers and _Jottrelated section numbers appears in the General Information Section of the "Text" catalog, Form AF-7697.

lllustrations contain basic group numbers only; therefore, it is necessary to refer to the baSic group within the "Text" catalog (Form AF-7697) listing for the complete applicable part number.

The driver'S side is the left hand side of the vehicle and determines whether such parts as fenders, lamps, etc. are right hand or left hand.

Model year application is indicated by showing the first year followed by a diagonal line to indicate continued usage in all subsequent years until the insertion of the last year of usage, which will then be inserted after the diagonal line. If no diagonal line is shown the part is applicable only to the year shown.

Example: 57

57/60 57/

indicates part used 1957 model year only. indicates part used 1957 through 1960 model years. indicates part used 1957 through 1963 in this catalog and for subsequent years as indicated in the 1964/ catalog (Form AF-7636-B)

For Rating or Warranty Plate data, Truck Series and Body Type Codes refer to the General Information Section of the "Text" catalog, Form AF-7697. The various Body Types are illustrated on General Information Pages V thru X of this catalog.

'til. TlU'N 'AITS

'ROC ED URI FOR USING CATALOG

Following is a recommended procedure for using this catalog.

GENERAL 'NFORMAT'O'"

If an inquiry is received for a painted radia.tor grille for a 1957 B500 model, use the following steps.

A. Refer to the Quick Reference Index on the cover of this catalog. The index shows that illustrations for "Cooling-Grille" parts are shown in Sections 80 through 85 of this catalog. The first Section (80) in this group will contain an index for all illustrations in Sections 80 through 85.

B. Refer to the lllustration Index at the beginning of Section 80 under the main heading "B Series" and the subordinate heading "Radiator Grille and Related Parts" and find an illustration for the 1957 B500 (Page 582).

C. Refer to the illustration on page 582 and identify the proper part. It will show a group number of 8200.

D. Refer to Group 8200 in the Text Catalog (Form AF-7697) and locate the year 1957 in the column headed "Year". Refer then to the column headed "Model" for B500/750 (which means B500 models through B750 models). The part number listed for the painted grille is B7C 8200-A.

HOW TO ORDER PARTS

When ordering parts, always give the complete part number.

In the event the part number is not known, the following information should be included:

A. Complete description of part. B. Model year and body type. C. DimenSion, number of teeth, Size, etc.; if possible rough sketch of part. D. If applicable to engine, transmission, axle, steering, etc., specify type,

such as 332 cubic inch, Fordomatic, Power Steering, etc. E. Advise how Shipment is to be made - Freight, Express, Air, Parcel Post.

EXPLANATION OF SYMBOL * * Symbol indicates part is not supplied for service due to the following:

a. Part is superseded and replaced as indicated in the description column of text catalog.

b. Part can be improvised as indicated in the description column of text catalog.

c. Due to its function there would be little or no demand.

Always refer to the description column of the text catalog (Form AF -7697) for possible substitution, or for material specifications and dimensions which may be helpful in fabricating or obtaining the non-serviced part locally.

--------------------- -- -----

III

IV GENERAL IINFOIrMATION

IIJRD TRUCK PIIRTS

CHASSIS aARTS ILLUSTRM~QNS GENERAL INDEX

Fol101Ffn~ is a general i*x of the major groups shClWn in the Chassis and Body Parts Illustration SectiQ11s. For more specific i.I1tormatlon Njer to tl:!e Index Page shown below.

MAJOR GROUPS SECTIONS INDEX PAGE Ace·efe-ratar Linkage-- - -97------+-6~ Air cfeaner------·-- -- ---··-9~-----t-- 611 Air Conditioner - -T%,I97---- -.-lr.JZ--Alternators - ·------r-· 160 ·---71r--AXle (Front)- ---30 ·--no--

AXle (Rear) --- -. 40----ng------------ ---- -------1-.

MAJOR GROUPS SECTIONS INDEX PAGlO Mllnifol(j .-- . --93------- -~ 'M~ir~r~o~r~s----------------+-----~--·----4---~8l~:32-

_~M~ill~D~e~r~~-----------·--~~ --------5A2--------~_-___ -.~2~~_:8.~0_-__ -__

Oil Filter -O~l~·l~Pu~m~p------------·--- 66

66 346 346

-Battery Carrier -.- ·iOS- - .- -·-'r~ -cR~a-d~"Ja"'t-o-r------------- -- ----'8"0 ..... i----+~61-Brake-s·------ ---- ---- ~tliril26 .-. -12-- Rear Axle ----40"--- 228 Bumpers 50 - ---- -- -S3r-- Rear Springs !:l5 :lilO -------- -----_.--.- ---------- Rear Suspension 55 280

Camshaft 61 .--- - --34e-- Regulators-·---- ·--[----------.1..,.17'<0----·--4--......,,71"90--·Carburetors· -------.-- . §5- --- ------srr-- -Runnfng -Boards ·---160 -----gnr--Clutch- 75-40-3-- 1--'=='""--""'="-"----

CooTing System 80.1 -·--SBr - .1'iston~ Connecting Rod·------: 61 ~o----Coupling Shaft 4-6-· -----z71--cranks-barf_&.. FlvW1!~€l ____ ~= ._---63 ------:r4O--

Distiibu-tors- -- .---- -- . - -------12-0----· 719 Drlve-Sh·aft .-- -.-- ---.- ----4-6-----·--- ---2rr---

19u1t-io-n Wliing----·-------- -- - 126 -.---. --.>tn--­Instrument Cluster---·-- - Mise.Charts - -- --r--

_~ __ 719 fustrumentPan~e-l'--·--------t----~M"isc.Charts ---~

Lamps 130 thru 145 ~~

BODY ILLUSTRATIONS INDEX

MAJOR GROUPS BODY SECTION J INDEX PAGE Door Parts -- -----------;-------'2"'0"'0,---------- 884

---~

-----

----.---.-. - - -- .--.---------.--t--------------------------------+.--------... ---t-.-----

MAJOR GROUPS BODY SECTION INDEX PAGE Sea~--- - 600 884

-.- r-----rSrt:h-:e-:-et~M~e:-"ta:;cl,----+--'8ifl8f.l4r--Sheet Metal ____ . _ _ _ __

Windows (back -a:ndslder --C--Sheet Metal & Exterior Moulding

Windshield--- Sheet Metal &

884

il84 Exterior Moulding - -- ._- --=--- .--------

------------- ---------l--------+----

BODY TYPE

66 (INTEGRAL PICK UP)

(1961/63)

81 (F-T SERIES)

81 (IN-lNT SERIES)

--- -------- -- --

GENERAl. v INFORMATION

86 (RACK)

3-70

P-4881

P-7503

VI GENERAL INFORMATION

FORD TRUll( PARTS

BODY TYPE.

82 (PANEL DELIVERY)

====~~~~~~~ (1957/601

82A (1969/1

lOS" W /B SHOWN-ALSO AVAILABLE IN 123" W/8

828 (1969/)

lOS" W /8 SHOWN-ALSO AVAILABLE IN 123" W/B

82C (1969/1

lOS" W /B SHOWN-ALSO AVAILABLE IN 123" W/B

P-7S01

FORD TRUC#( 'ARTS

BODY TYPE

84 (OPEN DRIVE AWAY LESS WINDSHIELD)

85 (PARCEL DELIVERY)

85 (OPEN DRIVE AWAY INCLUDES WINDSHIELD)

99 (STYlE SIDE PICK UP)

87A (STANDARD)

(1961/67)

87B (CUSTOM) (1961/67)

89A (1961/67)

GENERAL INFORMATION

VII

VIII GENERAL INFORMATION

FORD TRUC/( PIIRTS

BODY TYPE

89A (1969/)

89B 89C

(1961/67)

89B (1969/)

89D (1961/67)

FDRD TRUCK 'ARTS

BODY TYPE

890 (1969/)

lOS" W /B SHOWN-ALSO AVAILABLE IN 123" W/B

89E (1963/67)

89E (1969/l

89F (1963/67)

89F (1969/)

GENERAL INFORMATION IX

x GENERAL INFORMATION

FORD TRUCK PARTS

BODY TYPE

89G (1963/67)

89H (1963/67)

P-7504

FDRD TRue/( 'ARTS 1957

MODEL IDENTIFICATION

SERIES B500/750,F100/600 SERIES F700/900,T70C)/800 CONVINTIONAL CONVENTIONAL

SERIES P350/500 PARCEL DELIVERY

P-1828

SERIES (550/900 TILT CAB

P-2365

XI

XII MODEL IDENTIFICATION FORD TRUC/( IIARTS

1958 SERIES B500/750,FlOO/600 SERIES F700/1100, T700/950

CONVENTIONAL CONVENTIONAL

SERIES P350/500 PARCEL DELIVI!RY

P.1828

SERIES C550/1100 TILT CAB

SERIES FlOO /600 CONVENTIONAL

FORD TRUC/( 'PARTS

1959

MODEL IDENTIFICATION

XIII

SERIES B500/750,F700/1100,T800/950 CONVENTIONAL

SERIES P350/500 PARCEL DELIVERY

P.1828

SERIES C550/1100 TILT CAB

P.2582

XIV MODEL IDENTIFICATION

SERIES '100/600 CONVINTIONAL

FORD TRUC/( 'ARTS 1960

SERIES 1500/750,'700/1100, T700/950 CONVINTIONAL

SERIES P350/500 PARCEL DELIVERY

P-1818

SERIES C550/1100 TILT CAB

"·l57!

.'>

SERIES E100 ECONOLINE

FORD TRUC/( 'ARTS 1961/62

MODEL IDENTIFICATION

SERIES PlOO/500 PARCEL DELIVERY

xv

SERIES F100/600 (1962) CONVENTIONAL CAB

SERIES B500/750,F100/700 (1961) SERIES B500/750,F700/750 (1962)

CONVENTIONAL CAB

c,'*lfij

~I,-=--='~ ~pll-+----t--

._. __ ._._._._ .. _.,_ .. _-_ .. __ ._ .. _---- .. -.-.-----.-.-.-----.------SERIES F800 /1100, T700/950

CONVENTIONAL CAB

SERIES C550/1100,CT750/950 SERIES H950/1000,HT850/950 TILT CAB FORWARD AXLE TILT CAB

XVI MODEL IDENTIFICATION

SERIES E100 ECONOLINE

FfJRD TRUCI( 'ARTS 1963/

SERIES PlOOf 500,P3500 / 5000 PARCEL DELIVERY

--------------------e----·----·-· __ ._·._._._. __ ._._._. SERIES B500/750,F100/750 SERIES F800/1100,T700/950

CONVENTIONAL CAB CONVENTIONAL CAB

~= l1lc:,;)q;..~ ~

SERIES C550/1100, C6000/7000, CT750/950 SERIES N500/1100, N6000/7000, NT850/950 TILT CAB

~

SERIES H1000,HT950 HI-TILT CAB

89" BBC CONVENTIONAL CAB

SERIES W-WT1000 HIGHWA Y TRACTOR

FtlRD TRUC/( PARTS MISCELLANEOUS CHARTS, ILLUSTRATIONS, ETC.

1

---~~---------------------------~-----

----~------------- -------------

INSTRUMENT CLUSTER and INSTRUMENT PANEL PARTS

-----~------------------------

----~--~--~

YEAR MOD E L

I PAGE NUMBER ILLU~ NO.

1957/ 'B500/750 == 2 P-3555 IC-CT5-50/1100 1 10- P-3554

f}igg7750:l3OdY1'ypeSr ---- ------------ -I ----~~~---- ~=~~~~ ! FlO071IOO-Body Types8f;-85 - ---------- - ----- -_ --1_

1

- --_-_-__ -410~ -_-__ -=~P---33555543 r-H~HT-85·0!lbOO------ --"-- --- - .--------~--------- - -- - - ---- - - -.- --_. I ...

I N-NT50o;nOO 4 P-3553 1 P100/500 - - --------~-------I--- --- 8~ ___ ~R r 1'706;956- - ---- --~ -------~ ~-~---- -1-----~- -4--- , P-3553

--I ----t--~-------~+---

--+--- ~--+---1 ~-~

----i---------- -----------~---~

-- ~-~t- --+1-----+ ---------------- -------+- ---+1---

I -----------------!----------+I--------+---------------------------~ +1---

I ! f ~-------------------------___t;- +j-------+---- ~ti -----------1

- --+1---I ± ~~--~---~ ----~----~-~ -~--~---------~---- - -- ~ ------- . -

--~ I I I

----I-I-----------------------~[--------+---__ -----+--.I ---------------------------j':--- ---11-------

~---~------- ~-------------~---~- --~---~~~ ~- ------t-----~ ---+-1 -=-~=-~T=~---=--==---=--:-=--:-:- -~---- ~-- ~ -- --- ~--- (" ------~----=f---------r- __ ----±=

I

~ '" >-'l ~ ~

t?1

Ol ~ I "CI "'l > g ~ :::. t"'

g; ~ tOA885 I P-

Ol ::ll o t?1 t:I t"' >< > >-'l >-'l >< t?1 "CI t:I t?1 "CI 0> > .... ::ll

>-'l UJ

~.\

11!A952 <,

'-":::~:~~~~" ~T70;=~"~~~ ....... :;;; :l::~:······· 108~4 ~ J '':"'. (iI~' .. ~::: .... -<~.9A389 .' .' ... ~ 'JIe.' ... ~ \!!J'-~ .. <;..::: ..... \ :. .' .... ::.~;r:J!Jl\ \ 10883 .10852 .' .. ;~

.... ~~'"~,.M." ., f.0852

~.;

11582 3685~ 11661 . (I)

? 13466(7)

* SCHOOL BUS ONLY ... MODEl 84 EXCEPT SCHOOL BUS • MODElS 8.F 700/750 ONLY

. " l"i I! 06112 R.H.

P·3555

Nl

~ -iii '-n .-'" C.-11'.­..... ~Z =0 Oc ZII' II'n - :t "' .. "':oa !" ...

II'

2 o ;a c:: ~ ~ '" ~

MISCELLANEOUS CHARTS, ILLUSTRATIONS, ETC.

3

INSTRUMENT PANEL and RELATED PARTS

1951/ B-FlOO/150 - BODY TYPE 84

! Group i Part Number

__ 2A036-ts5TZ 2A036-A 2A204 C1 TF 2A204-A 2557 C3TZ 2557-A 3685 B9A 3685-A

Part Name

Gauge assy. (vacuum) Wire assy. (vacuum gauge) Gauge assy. (air pressure) Kev (ignition & door lock)

___ ",9-:::2,:-73::-+-' ~C~1:...:T:.::F,---.::.9=-27.:..:3.:..:-.::..A=--_hG;::a::u",,-ge assy. (oil pressure) 9280 I 8) Gauge assy. (fuel)

~i*C'1~l~ll··~~'9·A'3·42'-~B---+·W~1~·r·i-ng-a-s-sv-.'('ig-ru"t~i-o-n-s-w'i~tc'h---I to fuel pump switch)-(1961/62)

_~~C+-"'--;;'=:"""':==:-'::=--+7S;:.w7it'7c~h..."a:.::::ssy. (fuel pump control) Nut ( fuel pump control)

9A388 C1TZ 9A388-A 9A~89 8)

9700 '" 9775 (j;J

Control assy. (carb. choke) --:c==--=--+--cJ,--------+C~o-ntc:rol assy. (carb. throttle)

04810 C1TZ 8104810-B Receptacle assy. (instrument

04824 i C1TZ 8104824-A _~~-+~~~~~~~-+~pa=n~e~l~a~s~h~) ___ ~_~~ __

Panel (instrument panel ash

- 048261 C1 TB 8104826-A receptacle trim)

Retainer assy. (instrument panel ash receptacle)

_~0-=-6c:-01:-0-+--;-C:-:;1-::T~Z=-78=,10",6,",0c.::1,.;.0_-:;.A_+ Compartment assy. (glove) 06024 C1 TZ 8106024-A Door assy. (glove compartment)

374212-S Bumper (glove compartment)

06112 C1 TB 8106112-A

06113 C1 TB 8106113-A

06164 C1 TB 8106164-A I

Spring (glove compartment door assist)-R. H.

Spring (glove compartment door assist)-L. H.

Knob assy. (glove compartment door)

- 10-~---;8)--------'--+-R~e-g-U~I-afor (constant voltage)

10850 I Ell Ammeter

10852 , Ell Bezel "carb. primer-hold 10

-.-l~~.fi2i-~---=----------_-__ -_t-=--=--'t--=~-=:.::.~o:-:e.7;:~ii'-gCh~_L-s~'.'-__ -_ -_-_-_-.:~--_--__

= --~.~=---- -.=: -- --- -- -+------

=--1~ I

---1------------t---

---+----[---

-=l-~-----~--"-------. I -- ---1-----

----.. ---+-- ---·----1------T -=-~~I' --------. ----------"-~ I ----I---------t

-. ---- _.---1----- -------.----

: Part Number '

I Group Part Name

10A885 i E±i Plate{ignition switch mounting)

--'1~0"'8"'9'4+-ttJ-------~aSK (msfFumentclusterT·--I i lights· 1961/ ! e i Mask (Instrument cluster).

--.-------t ---J_ga_uges____ _____ _

10A936 IB9TZ 10A936-A i Lens (oil pressure warning I . ~lamp)

1~~93J B9T Z lOA9 37 ~~I \=e~cc'~"-'n=-;ic:c;n~-:a:-:~·~CCgm-::-e~~-)·'dl~· c"Ca'to-r----

11572T-e- ----r-swncnasSy. (!gnuro~n'"'")----115811--1A--nOlIT-:'B~rlng\IgrlltionsWitcll

I I retaining) ------r--------~------------------------

11582 ,!~------ i cyrrn~'kE'Ys assy. (!gIuhon -! L switch)

~..§i..~_~_ i BezeJ(lgnition switch) 11650 l ! Nut (light switch)

---. ---- --I -- ~ - - - - - - ---------"---

~=t-5)-=-j. S~itch aS0'",--'T.J",,~-cg.-cht_)._-_ --cc--:.----

__ 11661-....j_ EIl __ J~I1.<>~§shaft{gE~t_~\\1itCh) __ _

I I 13340 i C1 TF .1:> 340-B I Lens (instru. panel turn indicator ---C~~ : -l lamp) __ 1~66 T_.tB .. _~~u)bJillstl'u.m~nt panellightingl

I I 17255 I CITZ 17255-A Speedometer assY11ess ____ c--'-i~~ I mounting plate}

17289 I if ~-(SPeedome-termOuiiUng)

--17360-1 - EIl--tTachcnnefer assy ... --- ----17368 I BIT 17368-A ~cKef\fachometer mounting}

18A952 ! B7LY 18A95:2-A : Choke(radio receiver suppressio!il \ ---------- .

_._--+-- ---I

-+ --- --

-----1---

--- - ----

------------ --------

, ------r--,-----~,..---.------- ----+--_._--------------

----,--- --T ------;'--._----_._-------+--- --------------

, ... ----------1-----------------

I ------+---------------r---------------------_~ __ +_ _ ________ - --1---------------------------11-- ---. ---.--------.-----------

I ----j---

i - .-----t \ -t----- --+ ---.. -- --------

! I

- .. --t ----.

i Ell Refer to b:Lsic group number for prefix and suffix required

~ ..... >'3 <o:J:l

~~ M

>xjZ ,>'3 Z'i:l ,> ~~ ~I:"' ..... !ll 0::; op.

';::;::J:l ..... M 01:"' 1'> t:P>'3 OM t:!t:! ><'i:l >'3?d ;1>'3 Mrfl W,

F~ ""'i:l UlH

(')

~

FUEL SHUT OFF

339.45·$ (~.:::<: ... .-.- --­

~'0·1 (X:69) ~ 1,9700

.;,,~II ?fIOC935 n

/3394~S (M.37) 9700 10852

34810-$ (X-69) ~

AIR SHUT OFF

9218

13466 1f"1 'f"'~ 108S0~' )j:F;:~rJ

#F800/1100, TlOO/950 AALSO SUPPLIED IN 18805 RADIO KIT * REfER TO SOfT TRIM SEalON • SUPPLIED WITH 2557 ASS'Y.

t F700/750

A18808

¢USED WITH MECHANICAL fUEL PUMP-1962/63 (BEfORE SERIAL 370,001) _USED WHEN HEATER NOT INSTALLED 089" BBC CONVENTIONAL CAB WITH DAGEN HAM DIESEL ENGINE "SUPPLIED IN 18805 RADIO KIT ONLY

374212.SICC.26)

04320 PANEL ASS·Y. 04290 COVER ASS'Y . SAfETY

P·35S3

....

J: III

- n :: m c: .... ~; :a Z ,.. m

::! 0 o c: Z III

!!'n m % -t ,.. !'II :a

-t III

." : o ~ c:: ~ ~ '" ~

FORD TRUC/( 'ARTS MISCELLANEOUS CIItARTS,

ILLUSTRATIONS, ETC.

INSTRUMENT PANEL and RElATED PARTS - TYPICAL

1957 j F-N-NT-T100jIlOO - BODY TYPES 81,85

5

Group ! Part Number Part Name Grouo, Part Number Part Name 2557 I C3TZ 2557-A I Gauge assy. (air pressure) 10A937 +-' (l) i LENS (charge indicator warning-Iamp)-~ 3685 B9A 3685-A I Key (door & 19mhon lock) 10A960 [ ~'ll----~~lAMP<iDwe~idei.tJ!!i~!<.out Warni~)---7 A650 IA9AZ 7A650-A 1 Handle & Cable assy. (trans. 10A96~ __ g: ________ ~ ___ I LAMP(truns~retarder oil temp. warning)

I overdrive manual control) lOA962 ,C3TZ lOA962-A : Lamp(oil pressure warning)-

=-.'7.A.65~-+<::'lTF __ .. '7A65.J-A~r!cket (trans. overdrivecontrol ___ --~__1- _n 1963/ 'r 10A963 [ C3TZ -iOA963~A Lamp(water temp. warnIng)-9A050: j I Switch assy.(fuel tank selecto~ --1 1963/

9270 i C1 TZ 9270-A Gauge asSY:\fiielpresstir-er- ,-9273 [ ttl I Gauge assy. (011 pressure) 11572 C3AZ 11572-A ,Swltch assy,-ngnmon)~~----

-9280-+('1 i'F9280.:C----; -Gauge assy. (fuel) -------- 11581 II 1A TIDBT-n-:----sprfugflg-ii:~;wftcli-retalnlng!----99CC333--21~-*i~C13--T'I'FB--~9JC C; 3

3-23

01

-_::.tlE

_...J _ tlCoJrantCrK-o,e-lta (l1s-usey'-l.~frUeesls..Suhrue tolWf_aetu°.:1I-_ 11582 C3AZ 11582 -A 1 Cylinde r & keys(ign. s wit ch I iiCk)

I \ 11584 : C3TZ 1T534-A--:-rrezeTngnftr.)n~s\vrtCh) - - __ n_n

: : from C3TZ 9700-E - 11650 1 ffi - ---Nm(1Ig11Tsvll.tcfiT -! "Before Ser.370, 001" I (1963-N600/700 Diesel) --11654: 9 ---;--swrrCli(1ieadEimp)-=~-------

---,- ~ -------i--· - -- -- - - -- -~--~---- _~ll66L;_S _ __ --:-:-~:--rrnoo&SlianThea(jjan;p switch) 9A342' Ell I WIRING Assy.(jgn.switch to fuel pUttlJ switch) , 9A388i C1 TZ 9A388-A 1 SWltch assy. (carburetor pnmer) *13~049: C1'I'F'.-13A0i~:A_~;-E3:i1fIeJh~gh tea~ InciIcatclrTamp) 9A389 i CITZ 9A389-A : Nut (fuel pump manual control *I3A30:rTclTF 13A303-A ,Bame (turn s:£rialindiCatorTain;)

, ! & carbo primer switch) 13340 :C1TF 133j_O~TI-=-_~ns-(fUrrlTrldicat(;l' lamp)----"g~7~0~0-------+i--W 9700 Control assy. (carb. choke) 13466 i tt I. truIO(lnStrur1enfI1Q:/lti,lgr-----

9700 : C3TZ 9700-D 'i Control assy. (fuel shut off)- 13586Ti C1TF ~A~ns(highbi,am indICa-for-lamp) ["From Ser.370,001'' i 1963/66 N600/700D1esel

9775"':" @ 9775 [ control assy. (carb. throttle) 14064 : Ell-TWfreassY:Tlac11mneterTalnpr------- - ----------- ~----,---- - .--- ---- -- -.--~--- 14429 I FEW 14429-A : Fuse (cigar llghter)

- OT890jC1 T~Z- 810181)'0=13-; Control assy. ('vent: a:i~-- 14698 I C3TZ 14698-A WIre assy, (all' pressure gauge) 04290 I SEE SOFT TRIM SEC. [Pad (instr. paneI)-safetv ~15~_0~~_ (;1 TF _ 15A046-A : WIRE Assy. (cigar lighter tof~se panel~) -04320 i e : Panel assy. (lI1strument) 1505«, Ell , Knob & Element (cigar lighter)-04334, C1TZ 8104334-A 'I Panel (lI1str.panel end)-R. H. . : 61/

--':;0';'43~3~5;";"" .;;C;..;1.,;T,;Z;.......;;8.;.1;;.04;;3~3~5"'-..:,Art[--1-;P.:;:a~n:;;'erl T(ir.n;-;:sitr;::.~p::';a~n;;:ejl'e;;:n;;1dc\-) _:lLr--. Hr:>. - -~1"5""0'"5-5 --i: ~~X-TSOc;;,k-OCe"tc-.&,-rMZ'7e=ta~l·~n~eiTCIgar lIgh te r ) 04439 [COAB 64D4'f39-F I Retainer (lI1str. panel mouldll1g) _~1~Q7~--L~T __ _ _ __ =-~Passi---:(clgar-rrgnfel;r----

044A98 ~ CITZ 81044A98-A Cover(wjs defroster reL) -R. H. --, - ---!- --- 15A404: Ell I Wlrll1g(marker lamp to switch)

04518 i C 1 TB IllU45Hl-A Nlouldlng-R". H. -1961/63 15A405 : 4 -- , Wi rea s sy:- (fnai'KerTamp~s\d{cj]-04519 , C1 1'B 1l1U451\i-A Mouldll1g-L. H. -1961/63 I : to headlamp switch) 04551 C1 TB 8104551-A Reinforcement (to dash) ~ln5"~[7j"_!"4---j-;g"<C}"'TmF"_-.J5"A4 !3-A~-: NlitTma-i'ki:;rIamp swltcnreC r-04589 , C1 Ttl 1l1U4o~W-A Moulding (center) 04810 , CITZ 1l1U41l1U-tl Receptacle (ash) 15443 [ $- :--BwItd1TmarKE;rlarllpolfriKE'rl--04824 Cl TZ 81u4~24-A Panel (ash receptacle trim) _ !Si69 _ _ Ell ·1TIeZel rmarJrerlamp-i;wTtcli) -

__ 04~~;Cl T~ 810482~~t-- ~~talner (a.s_t.recepta.~_~_

06010 i CITZ 8106010-A Compartmenngrove) 06024 . C1TZ 8106024-A Door (glove compartment) 06112 I C1 TB 8106112-A I Spnng (assist)-R. H. 06113 : C1 TB 8106113-A I Spring (assist)-L. H.

_ 06164; C1 TB __ 8106164-A_~_Kn~b (glove co_mpartmeJ1t..c1Cl.o.rL

10804: ffi I Regulator (voltage) _~r.Q.84!.c. __ ffi. _~ ___ . ___ .l_P~~tE?..(back)-lights ____ ~_

10850 i C1 TZ 10850-B i Ammeter-196rl 10852 i C1 TF 10852-A : Bezel (fuel tallks)

: CITF 10852-B I Bezel (carburetor pnmer) I C1TF 10852-C i Bezel (lights) : ~!.!_12~2 -v...J.....Bezel (W_lp"'-.e.;;-;r='),-----------,C3TZ 10852-A I Bezel (pull to stop engine)

10876 'C 1TZ -10880 :ClTF

10883 ,CITF 1OA885 . C lTF

10894 : CITZ l0A93£., Ell

1---/

i

----- --r---- . -- -- - - ~--

10876-A : BezeT\Ii1sfrument cluster) 10880- A I Glass (mstrument cluster) 10883-C 'Gauge assy:-[temperature) 10A885-A Plate (ignition switch mounting) 10894 -C 1 Mask ,

__ j_ ~NS(Oil press.ind.warning la.mJ'2 ,

----+-1 ----4--

- ---+ --------1-----

___ ~ ___ .1 ___ _

--l ---~--I--

Ell Refer to baSle group number lOr prenx ana SlllIlX reqUlrea

---.17A553 i_~.c Switch (windsllleldwlpel') . 1 ,

--1"8"'5"4"5-+:'C"<C1"'UnF"---TBS40-A- --rrut (Tieafermower 8wflcfi) 18578 I '" --~. -- :----swrrch -a-s-sY:- (nealeI;-blower)--18598 iE!l.-~:"'~ ____ .. -3~~_(11~il.f_e!--:5I?:wei's\vitc:T1) -- -18607 i C1TI3 18607-A Cover (heater switch opening) 18805 : ---------- --1fadJo k:1((fess-~ri.tennaT - --18808 I _______ Speaker (radlo)-- -18817 '·-Kli05(rad-io)---~ 18830 : C3TZl883o:A.-- 'D\sc-(radTo--f6rtecontroI) --~ -~-

18A952 I B7LY 18A952-A Choke (radio silooression) _ 18985_:_CgTZ-18985--A -G-rlfle-TI~aalospeaker) _ - --- -

-- ~+----- -+---

[ ----, ...• _____ ~ _ ---.L __

, -- -------+--------+-

=--- --~-~r [

~ ~ M

~~ g;"Cl '->

~ PJ

M::> ... 0. 0::0 oM

t"' > '"'l M t:J "Cl > ::0 '"'l C/)

\\

• 06081 I I

06010 • 06095

•06050-e ~

10880

P-3556

0\

~ _iit '-n 1':' ... c;;.-"'.­.... ilDZ .... :::!O oc Z'" ",n - ::z: .... .... !" ... ...

... Q ,.. " ;J c:: ~ ~

--;::

FtJRD TRUC/{ PARTS MISCELLANEOUS CHARTS, ILLUSTRATIONS, ETC.

7

INSTRUMENT PANEL and RELATED PARTS

1961/

Group Part Number Part Name

3685 I B9A 3685 -A i Kev (door '& ignifionTock)------m718 : C2UZ 3B718-A:-stiPport assyTsteering column)-

; i 1961/ 3B741 ! C3U=Z~--~3=B~7~4~1--A~---~etal11eiassYlsteerfng-COIUmn­

: support) __ 9_28Q..j.C}'rF 9280-~-JGilUgeassy.\1Ue1} _______ _

I I 04282 ' : Pad (instr. panel)-safety 04320: ~ I P I (. t t) 04326 '", : P~~:I (~~~t';·~~~:"':'':~''.t)'--------

-~0~48:c.:1C;i0~:'-cC~1"U·"Z'-- 8904810-A : Receptacle (asnj ~,- ... -----04826 I C 1UZ 8904826-A ! Retainer (ash receptacle) -- t 1 ---- --

1\56OA~ Ell Cable (check) 06010 : ClUB ""1r9'0~6"'0"1~0~-~B'--+--"'C~o·"'mpartmentaSsy. (glove)

I 1961/62 : C3UZ 890601O-A Compartme11tassy.Cglove-)----

: 1963/ 06024: ?: ----:-rJoo~-assy:(glovecompt.-)---

~06050 : C3UZ~0~fflrlge-assy-: (gloveco-mpr.ao~ t06064: C2Ur 8906064.:x-iC8.fCh(gIo-ve-compartment doorF

: I 1961/ ~OG064 I C2SZ 630GOG4-A: CatCfl(gfovecompartmenf(J()(Jr)-

I • : 1961/ -~"'0~G~0~8~1~!~C~3~UZ8906081:::X-;Lo-d~-assy:(gfove-compCdoorj---

MG095 : COAB 6406095-A ~cutcheoll(glovecompartment ___ -I. _, door lock)

,

06142 ,C2UZ 8906142-A ! Striker(glove compartment door)" , 1961/

~06162 ! C3UZ 8906162-A _: Bumperfglo-ve cOinpal·t~e!1t do().rj

-----~ .---.-,- --- -1-________________ ----10804: 137A 10804-13 I Regulator (instrument c1uster--

E100 I

Group Part Number Part Name

11582 :"C3AZ 11582-A

116541 Ell Ii switchassy.(headlamp)-1961 11.66}~ __ Ell _! KnOD&Sh~r lheadlam~wltcliL

I

13AOGO : CIAF I

13350! Ell

13A060-A '-;-Retainer (headIamp junction : block) (1961) ~sher assy. (emergency ! warning)

13466 i 'i----- - :sulb (instrument panel lighting) 14429 I FEW 14429-A I Fuse assy. (cigar lig1iter) ---------i-- - ----- -----~i- ------- ------~-" -- - ------------

15052 i Ell ' Knob & Element (cigar lighter) 15055: EP Socket &-Retamer (cJgar1lgl1.Ter) 15583 I il) Switch (emer. warning flasher)-

I (1961/62) 15B590: :, ------ ~ Switch & wiring (emergency

-1 w.a:.rninK. f1<l:.sller) __ . _____ _ I ____ ---1. __ .

i 17255 :CITZ 17255-A ! Speedom'2ter assy. (less

, L mounting plate) 17260 , 0 l-cas:';i:;n:;g':;'&~s:"'h~a;f:;:t .:;:( s~pc-e"'eC-Cdrco""mC-eCCt~e-r~) -17264 : ClUZ 17264~A : Bracket (speedometer cable

I j mounting clip)-1961/62 -"-1 "",AA<1'2"'1Orr'-, "'C"l Tr 17A2'IO-A !JoInt assy. (speedometer a~ ~--.-,~""i--r -___L drivel (196ti62)

17289 : CO'FF 1 7~ i '1'lafe TSPeeao·"'mC-e~tC=e'CCr--'m''C'Coccu'''nt~i~n~g)~ 17512 : c:roz 17512-A i Nut (wIndshield WIper control)-

I I 1961/63 ----.1""75~1"3,,+-:~:sc----~ i Knob (windshIeld wiper control)

17 A55~ ~ .'u I Switch assy.(windshle!d wip.~~L _. .l .. i voltage) TosS-O: Ell - --.--: Ammeter 1

10852 i c~lU852=C I BezerTriglltsr--- 18534 I 0 Knob & Insert assy. (heater : Cl'l'F~lJ--~ezel(WlpeIT--------- I regulator control)

-~1~0=8=76-+1 ';;C';l';:U';;'F ----ro8'il)-:P;:P- ''''Bezel----------·--- ---.c18"'5"4'"5c-T-1 C7'<1"U'T'F~1"8"'5r;<4""5--A~~~N-u nneater-'b"'l'-o"'w"'e.c.r~s~w~i~tc~h~)---.---~--- -ul, - ---------- 18578 I 6' Switch assy. (heater)

10880, B7C ----rmmu-:p;:-i Glass ----.----- 18598 !C11JF ~1i18~5:l\g)l;8::--AX--~f'1B'Oe~ze;;l1r7(T;hiea;;,t"'e~r-lb;l~ow~e·~r~sc::w"ir:tc:l:hT)---rosas r cl UF 10883-A J: Gauge (temperature)-TIlO1)r--! with hot water heater

10A885 : C 1TF 10A885-A 'Plate (ignltiOl1SwItchITiOul1tIi1gJ i rC;-;lTUTiF;;-'1°8"5n98°-'B,,---,r-;=;B~e-=z:e-il (;:'h:"e-:a';:te~r:":'b:;lo'::'w=er:':"'s-w-i""tC~h~)---_ 1089~..:..~3TZ 10890-A~ask~ligh.tS . 188051 i, ,", With gasoline heater

_-,-=im'-t--;;wc-______ ~e-,.K:=it~( r:.:a=~dio -Ie ss antenna) ~1=0~A~9=3=6-+I~B~g~T~Z-~1~0~A~9-36~·-Lr;::en::cs:::-(r:o"'ilr:p:-:r:-:e:-:s~su-r-e--w-a-rm-·~n-g~l-a-m-p~) --,i>1t1:r~~T~..,-tI-;:~, ______ 1 Speaker (radio receiver) ~17<0.:xAi9"'3i,7-+! ... B;,;3"T;,:Z;;;---i1,;;0C,AC;;9C;3;:7~-;A~~L:':e:.:n~s'-'(;.c~hc!:a::.-r..:::g..:::e~i'=n:,.dl:::.·c.c:a~t::.or~w~a'-'r'."'n:2'i~ng:!.L I w T1'illob (radio receIver) _-r;,.,..."...-+~~~~~~~~.l__lamp)-1961/ _~-,'1~88~3'"~~-'C,,3.;;T.;;Z:--;c18830-A : Disc (radio receiver tone control)

11572: C3AZ 11572-A SWffCllassy~. ("'l-gn~I~h-o-n! }898~ c:;OTZ 18985-~_; _G!:ille (rad~o ~eceiver_,.sP_e_aj{e~L 11581 ! 1A 11581-B Spring(TgnillOn switch - ---_---L __

I retaining) - --~--~ __ +---__ .. ___ __ I

______ .L..._ -----~--­

I I I -----T-·

~--+----

I =:-- l-~­-L--.j

----~-.--~--.--I

- t --1- --

---.~---+---

------t--. ------+_.

i

-~ ..J

____ L

-- -~ !

* Refer to Grouo in Soft Trim Section ~ Used with steel glove compartment door

... - ~-

-I ---t-

I

I ----r---------t-- --

-+ -"---.- --+- ---

__ J __ _ I

=:--~--- -----+~ i

-----,

Used With oadded Instrument oanel onlv '" Refer to baSIc group number for prefix and suffiX required

8 MISCELLANEOUS CHARTS, ILLUSTRATIONS, ETC.

PART OF 01610 (1957/64)

11661------, 1164~1------_,

17513------" 351049-S (MM- 213) *175u~--__

I

( \

FORD TRUC/( 'ARTS

17470

* SUPPLIED IN 15583 FLASHER ASSEMBLY

rnSTRUMENT PANEL and RELATED PARTS 1957/ P100j500

34803-S (X-60) 79-S(M-163)

'~. c:.._

3466

P-3557

FORD TRUC/( 'ARTS INSTRUMENT PANEl and RElATED PARTS

1957/ P100/500 I

MISCELLANEOUS CHARTS, ILLUSTRATIONS, ETC.

9

Group Part Number Part Name Group ! Part Number Part Name i

3685 --SlJAm~ I Key (lgnTIThliToCl() - ~ -- -- -------I-

~71-~- 1353 -- 9271-A--tclusteraSsy. (instrument) i (less instruments)

--t -- __ "-- - ___ _

-9280---B7J9280-A i Gauge a-ssy. (fuel)-------~- -- ---> -- -- _ ----+--- _ -- .-- _ -- _ -------

9700 Control assy.(carh. ch~ke) I

-OTS!jO--1T8501B90-A------r---conrrOITventIlator alr)-R. H. ,-I

I

-~1"1"5"8n2 it I

~ __ ~ _____ 1_

11654 ' Eb --- ------1-

-~--C-ylmder &keys assy. (IgnIfioll-• _ switch lock)

Bezel (ignifion- switch) --

;13e!eI(j1eacila-mpswltcTl)-:-=-- - _-_~

: S0tchassy.(hea<ilampx: ~ ---~---

--0189r---TJ8:)0TmTl-A __ 1 ControITvenhlator alrJ-L. H. I - ---- 11675_t_m)CTTon~A~p_acernle~dl<lmp-Swit.c_h)~~~--=-

-----, ~eglllaf6f (lnstr. CTUStervoltage) I e I - - ------r3350!Eb -- -- ---- - -;----vIasFier ( emergencYwarmngT-

10817 C1TF 10817-C

10847

10A860

__ J _A_mmeter -ova! ________ _ i

- - --;---Plate (iglUtion switch mounting)­I 1961162-refer to Group 11597

. (:31'2 -IOA860-A 1 Plate (ignition switch mounting)-_ }~3/ ___ _

I

-------to ---

----t----:::::-- ---__ 1;3.466 _~,

14605

14608

15583 \ 'f

- -:-Bulb (instr-ument oa-nefli"htln,,) .

" WifIng assy: (instrurrlel~tpanelr

~--C;-rommefCw1I'Ing thj>ilaas1ipa:ne~

-'-1tetalner (grommet re1alnfngln--, dash panel) .

Switch, Wiring & Flasher assy. (emergency warning flasher)

T0883~~B7J-=-10118~~~1~Gauge-(teln-p--e!:.afureT==~= __ =17255TC9TZ I7255=-C =.- Sp~eaonietef

---115'12--- ED ---I ~wltch assy.\lglllhonL__ ___ i

11581 . I 17260 1 -ffi--------~---~-c-asm.g &Shatt_(speeaomeJerT-

lA -1158(.:-n--- i spriii.g-7Igllition switch ---1-

-t retaining)_________ }74~QJ tP-

---+ --- _ I I .. ----- _175~~ -jC r'75i3-A~Kri6b\Wrnas1lieIdwlpe~~ontr°li

- ___ --1-- _ ----------!

___ L

-----'--

j ,

- - --"

-i I

-- --t --!

--t-,

---r-

'il Refer to Basic Group for complete part number

z CJl

~ ... ~ ~t'l .:::~

'U 0:'-

~~ ..,r' I ::x:PJ I ;:J

::X:'" ..,~ ",trI "'r' 0:.--;::-.., ... trI go

"d

~ .., CJl

17470 (USED WITH

10894

158590

_~__ 12466 8~34653_5 (M_106_X) -- ~ 9 10852 10920 ~.~~/--/ 17513 ~ ~~_ii / ./

//;~ ~;~~ /.£i, .18808

* 50514-5 ~. ... ;~~"'50448_S (WITH PAD INSTALLED) ... ,- - OR 372036-S~..::: . 50438-S (WITHOUT PAD) ... /).of (U-122)

~.18985 I~

J ,..-_ .J "'355987.5 J.

11572 \~~~.~10A920 ~~// ~10A922

!Iii!- ..-/' - ,P ~ ..,--- ~ .---. 2535

ALL MODELS EXCEPT

FORWARD AXLE

8817

\FORWARD AXLE MODELS\

P-3554

"""" ~

~ -iii ~l' C~ III ... ... ~ ;IIIZ ~'" "'0 OC Zlll IIIn , ::t "'~ "';111 !'jiI

= " ~ c:: ~ ~ ,., c::

MISCELLANEOUS CHARTS, ILLUSTRATIONS, ETC.

II

INSTRUMENT PANEL and RELATED PARTS

1957/ C-CT -H-HT550 /11 00

Group I Part Number I Part Name 2557 C3TZ, 2557-A Gauge assy. (air pressure) 3685 B9A 3685-A , Key (ignition & door lock)

9A049 II Ell : Plate (fuel pump selector control i name)-1961/62

9A050 C ITZ 9A050-A I Switch assy. (fuel tank selector) 9A061 I C1TB 9A061-A I Bracket (fuel tank selector

1 control valve mounting) -(1961) I (1962)-use with tilt tandem only

--9270"iCltZ-9270:'A.- -'Gauge assy:-(!Uel p-ress.y:T96TT 92731 Ell . .r~~f/ assy. (oil pressure)-

~~TF9280":B---aa-uge -a:ssy.\fUeI)-19617 9A334 Ell Control assy. (fuel tank

1

selector valve)-(1961)

I (1962) - use with tilt tandem only

9A342 I e I Wiring assy. (ignition switch to fuel pump switch)

9A388 I ClTZ 9A388-A I Switch assy.(fuelpumpmanual I ! control)

9A389! Ell : Nut (fuel pump manual control) 9700, Ell I Control assy. (carburetor choke) 9775 : '" : Control assy. (carb. throttle) -----_._,- --~ ---_.-------,----- .~--- -~~--

-OTii90-:B9C-810f890::A-j Control assy. (vent airj=I959jtlO 1 C1TZ-- 9101890--B, Control assy. (venf.afiT-I9W-

03626 I Cl TZ 9103626-A I Moulding(w /s garnish)-lower 03638 : B8T 9103638-A ~upp6ff\W7Slower garnish mldg.) * 042110 1 1 Pad (safetv)

04297 1 B7T 9104297-A Mldg.-L~._H-,-;' ___ ~ __ ~----'_ 04439 I D6A 7004439-A II ~etainer (instr. panel moulding) 04810 B7C 8104810-AP Receptacle (ash) 048Wt mc 8104826-A IRetainel··(;~a-=shi:--:-r:-:-e'-::c-:--ep::-;tC:a-:-c'le")---

~ 04830'-1_- B9'(-8104830-A1Krioolglove-comPt.aoorl'"}~'5'IJ6"f

__ ~~~~mM~~~~~'-TI,, __ ~~-~"~~~~~ __ ~---06010 C1TZ 91060~ Comp<lJ:.~ment assv. (glovel

__ ""' ..... ~,,*"'353907 -S -.----J. Bumper (glove compt. door) 06024 C3~ 9106024-A I Door assy. (glove compt. )

#06064 I C2v<I 6406064-A I Catch (glove compt.door lock) H06072 ~C1TB 9106072-A ! Latch (gl.ove compt.door) 06112 ~ D7C 8106112-A I Spring(assist)-R.H. 06113 I B7C 8106113-A : Spring (a"'s::":sl""s7t')-·L":'.~H'i-.-~~~-06164; C1TB _ 8106164~A i Knob (glove compt.door')~1962/_

, ,-~~---------10804 I Ell i Regula.tcJr (voltage) 10B841 ClTF lOB841-A j Retainer -as'--sC-Cy-.-'(Toi.ccn'-st'-r-.-c-on"'Ct-r-oO"I-

I I cable grommet) 10843 I C1TZ 10843-8 ! Plate kit (back-printed circuit)-

I I 1961/

10850 e : Ammeter-108850 !CITF--I0B850-AP ~ Cover(ad,lPTerllOusingj

10852: B7C 10852-A : Bezel-wiper I B7C 10852-B : Bezel-choke I B7C 10852 -E I Bezel-lights

I ~;i ~g:~;:~ I ~:::i~~:~~er---~~~-~-I D7Y 10852-A i Be=--z,-e,.I-:-t_hc-r.o-.,-tt_le=---=C"--=-""-;""~-:--:-7 i C-:1TF 10852-B : Bezel-car.b.primer-i101d 10 second.

. _ I Cl TF 10852-A : Bezel-"L. fuel tanks R." .

10876 COT<I 10876-A ' Bezel 10880 Ell , Glass 10883 Ell Gauge (temperature)

<1"O'A"8"85c-r!-r;C'1"'TcrF;---Cl"0"A"8"8C=5--'A~~! Plate (ignition switch mounting) 10890 i Ell I Mask -----c.-------;-~___;_c;__ ___

Group Part Number Part Name 10A961 I*C1TF 10A961-A Lamp (trar:s. retarder oil temp.

: -----;;o;-~ ____ -+.w-:a-r-nc-ing-iT-)---'.1961/62 I Ell Lamp (tranccs'-. "':'re-'t-'a-rd·e-r~o70il~t-e-m-p-.-warning)

10A962! Ell Lamp (oil press. warn.) j rC"'3iTiTryZC---;17\01AT,=<962'.-AA--t~La"-::;-;lm~pT.(,0:Tilr.p~'rC;;:e-;:;-ss-:-.--::wa=r-C:'n.'-')--1<i9"'6"'3/-,-----

lOA963 , Ell Lamp (water temp. warning) ! "'C"'3"'T'''''--<I'lr7nUAU""'11o"'3 ----c. A.-hLa~m'~p::i)\';;;wa=te"r;-,:t--;:em==p~. :::wa:::-r=-:n"i=ng:3);Tl""96"'3"'/

__ 10~..s~J.B9T_~0989-A __ Ga,~k~t (a.~l-sgueak) _____ u _

11572 11581 11582

I

1A 11581-B

11584 C3'1'<I 11584-A 11650 Ell 11654 8)

Switch assy. (ignition) Spring (ignition switch retaining) Cylinder & keys assy. (ignition switch lock) Bezel (ignition switch) Nut (headlarnp switch) Switch Jhead'--la:-:mC-:-::p") --'-----~-

-~~--.~ .. - - -- -_.

13340 CITF 13340-A I

13466 @

13711' (B 14401 ~ __ 15052, Ell

15055 I e

15A4041 @

Lens(instr .panel turn ind.lamp}-1961/ Bulb (instr. panel lighting) Socket assy. (instr. panel lamp) Wiring assy. (instr. panel) Knob&element assy"lcigar lighter) SOCket & ret.assy .( cigar lighter)

I Lamp assy. (cigar lighter)

Wiring assy. (marker lamp to switch)

15A413 C1TF 15A413-A Nut (markerlamp switch ret.) 15443, Ell

-I5""4tWT CIT:F-15469-A

-- .\

_. ~B'w~t..~~as~~~onalrker la_~lJ!.nge~; ezel,mar"er amp SWlLCu -

1961/

17255 I Ell Speedometer assy.(less printed I circuit basic 10843)-1961/

-"17"'2"'6,-,;0-+1----,;----------+-,s"'p-e--ced·o-m---,-et~e·r cable assy. 17264 i e:- Clip (speedometer cable) 17 A270' (B.jOll1t (speed.o. cable angle drive)

_17289 J (B u _ t'lale\Spe_:aom~ter mtg.)~ _

17360 Ii ==~ _____ .--t~T.:.ca~ch,'_o:c:m=et=.::ec::.r..:c:::Ls:.::s"'y--'.---c-.---,----

173 6 5 ,__ ___ _ ___ . __ -t~C~a-'-bc...l:_;_e-'a7s'-is.;'v-'--. +(.t'-'a~c"'h,oc.c.:m'_'e'_'_t:;...e r,~l'-c: 17368 I Bracket (tachometer mountin~

174'7Oj-,:-" ~---- - Control assy. (Windshield wiper) 175 12 , (B-- .--.- --+~N-~l~lt~(-w~in-d'··s-~h-7-ie~I'~d-w-l~· p--e-r-c-o-n-t l-·o--'l~) ---'

17513' ,-:, Knobassy.(w/swiperorheater)

* 18532 18532 Bracket (heater-control mounting) *18532 ~1ll532_ Bracket(htr.control mtg). reClrc.

18552 B8T 18552-A Control assy. (heater) -T8578I--'--- ~--. Switch assy. (heater) *18A586 18A586 Wire assy. (heater switch to

I blower motor)-forced air

-'*'1"8'A"6"'68~---- i"sA668" -- Bezel (heater control) ---__ ~ _~ ____ ~_ Radio kit (less ante 1111;,L ____ _

18808 Speaker (radio receiver) 18817 -- _ ~~ (radi~ ___ ~._---=~= 18830 C3TZ 18830-A Disc (radio 18985 COTZ 18985-A Grille (radio receiver5i~)-

18A952 B7LY 18A952-A Choke,(radio suppression)

--

-- . '---~A898 I ClTF ~10~A~8~9~8~-~A-rcrommetlTnstr. control cable) 10A920 , (B i Wiring(Tow vac·. warning light) _ 10928 I C 1TF 10928-AP fHo-llsing(Iiistr. cluster adapter) _ _ }

J 1-- - - -t--Ell Refer to baSIC group for prefLX and suffLX reqUlred (; Used with printed circuit board

# Used on H-HT850/1000 only * Refer to Soft Trim Section

12 ILLUSTRATION SECTION 10

'tiRO TlUeK 'ARTI

INDEX

THIS INDEX SECTION INCLUDES THE FOLLOWING MAJOR GROUPS.

BRAKE AIR CHAMBER BRAKE BOOSTERS BRAKE BOOSTER INST ALLATION BRAKE and CLUTCH PEDALS BRAKE MASTER CYLINDERS BRAKE SYSTEMS

BRAKE WHEEL CYLINDERS DIESEL BRAKE VACUUM PUMPS FRONT and REAR BRAKES PARKING BRAKES SP ARE WHEEL CARRIERS WHEELS, HUBS and DRUMS

YEAR 19. _

TIT L E MODEL I SECTION I PAGE I ILLUS, NO,

B SERIES BRAKE AI'R CHAMBER

63r---Parkfilg brake & siliety all' chamber-rear wheel (Maxibr3ke) IB600/750 21 149 _~413~_ BR'AK'EBC'OSTERS ___ ---''--__ --'_--L __________ ...L. __

'5'i/62 . Brake "Dooster--(ail')-

57/62 6!l( 63T--63/

Brake BraKe

booster (vacuum)(12 3/4" Bendix diaphragm type) booster ·(Vacuu.inHdasn·mou.mearrMRITand-Ross) booster (vacuum)(12 3/4" Bendix diaphragm type) Brake

~raKe 'l5OOsIer (vacuum)\ll" Bendix diaphragm type) BRAKE BC)OSTER INSTALLATION

~---BraKeooo­

'6'1[6'2- ---BraKelloo 63i---BraKeOoo-

sIer ,vacuum & air)(Irame mounteo) - Typical ster-CVacuum,Kframe mounted) - Typical ster (vacuum) (dash mounted) (Midland-HoSS) and

frame mou nted reservoir installation BRAKE & CLUTCH PEDALS

. '57/ Sou-BraKe -&cTutch-peaa.1s&reI3:'fe<Iparts 61/ BrakE & clutch pedals & related parts -----BRAKE MASTER CYLINDERS

!B'Wuj'I:Ju B60~750 B:Juuj'l:Ju

B600/750 B'IUUj'I:JU

,B6007750 !B::>OU

I i

--B5'Oo/750

IB500 750

577 _ BraKE'ITlaster-cylinoei'-':-Typical IB500/750 --'8RAKE'S'(STEMS ------- .....:.:'------------------61/ . -Aii-o :rake syste-ffi-':--rrorU seCtTon-installation (8 cyl. 292) 61763- Alrb rake-system--:-Tr'ont sectloii.-fnstallation (8 cyl. 302, 332) 61r7~.irb 6IT--- Fron

eraKe-syste'm:-:--iear-sectionlnstallation - Typical

t brake air limiting valves '5'7/00 Hydr 57160- ---}iydr 00 Hydr W--- Hydr

aulic brake system - Typical aulic brake system - Typical aulic brake system (with vacuum booster) - Typical ~tulic vacuum brake system with frame mounted vacuum boosters and vacuum reservoir installation - Typical & air

·tIT{6'2'---HY<:rri aulic vacuum brake system with frame mounted vacuum boost er - Typical

B'3l-- Maxi air parking brake installation & Tractor Trailer Emer 'gency Air Supply

63;--- Maxi 'air parking brake tube installation with Eaton & Timken 17M, IBM rear axles

. ----.---_ ... BRAKE WHEEL CYLINDERS

B600/750 B600/750 B6007750 B700/750 B500/600 B700/750 B500,.'750 B600/750

B:>OO

BoOO/750

B600/750

23 23 23 23 ZOj

.l 22

.! 22

I 23

129-

127 130 132 1;J3

115 122 136

-p:Wf3-----

P-1481 p-'4nS-'"

P-4216 P-4217

P-5248 P-5263 P-4160

-P~232I-­

P-3584

,-;;---- --'----'--L!~_ ~;;..._ ~:38'0 __

22 67 P-3874 -~--~ ~-l--'P:'38i5--

22 101 P-3870 22 51 P-23I7-

22 53 P-1482 22 56 P:3203--

22 115 P-5248

22 122 P-5263

22 89 P-4550

22 90 P-4553

57/ . . Front brake cylinder - Typlcar----·---·-- P:':f423--- . -5~' ----Rear brake cylinder - Typical p-1424 FRONT-GIld R'EAR-BRAK ES '-"--_____________ --'-_--' ______ -'--___ -'--__ L-. =-=--577 FronC ana rear-cam air brakes - Typical -57/ Front brak e - Typical 61';---' '---Frontbrak -57T Front brak "577 "---'-'Rear brake ·57;-;----Rearbrake 1 '57j-t--Rear brake fliT' 1 -Rear brake ---'PARKING BRAKES

e (14" x 2 1/2") - Typical e (double anchor type)

- Typical ( 5" x 4 172") - Typical

-(except 15" x 4 1/2") -~ Typical

"S'T/5lf·--·····-ParR mg braKe - TypIcal .ing brake - TypIcaL '5775'S---Par1i

--s~--ParK

w-t---Park illglJi'aKe system - internal type - Typical ~~_~r.."ke (mternal shoe)(9" x 2" & 9" x 3")

SPA-RE WHEEL CARRIERS

BoOO/750 B500t7OO B700 B700/750 B500[750

I B700 B700 B750

BoO~eOO B'lUU/'IoO B500/750 B500/750

5'11' ----Spar':;-Wli.eelcarrle-i\fra=-n:ccl-.,.e-n"Cloc-u-n:'i:t-::-ed"')----------I B500/750

i 2'1 44 P~206-2--

21 42 P-3718 21 42 P-3718 21 43 P':-206-3--

21 42 P-3719 21 42 P-3719 21 43 P-2064 21 43 p-26if.r--

-------

26 152 p-1414 26 153 P-1416

I 26 159 P-3229 26 154 P-2848

14 I 38 ~-P=532-2--

FORD '1IUCN "ARTS

'*' INDEX

TIT L E MODEL

B SERIES

ILLUSTRATION SECTION 10

SECTION PAGE

10 31 10 ~ 10 33 10 6

13

ILLUS. NO.

P~T390----

P-3523 p=TI85--P:3S~-

BRAKE AfRCHAMB~- _____ 0 ___ _

~r L=-parKfngoraKe-&-salely-air ehamoe-r-~i'earwneer(MaxlliraKeTICo(j07IooO~CT'i507950T 2C I 4!':f-T-p::<l13f­BRAKE BOOSTERS

57/62 Brake booster (10" Midland diaphragm type) 57/62 Brake booster (air) 57/62 Brake booster (vacuum)(9 1/2" Bendix piston type) 57{ti2 Brake booster (vaCuum)(12 ;J/4" Bendix diaphragm type) 6;s Brake booster (vaCuum)(9 1/2" Bendix piston type) ti;J/ Brake booster (vacuum)(12 ;jj 4" Bendix diaphragm type)

~;' Brake booster (vaCuumJ\il" Bendix diaphragm type) BRAKE BOOSTER INSTALLATION

61/63 BraKel)oosteTevacuum)\.l'i'ame mounte<l}(l3Cyl.29 401,477) - Typical Bra e oos er vacuum rame mounte Diesel) - Typical BraKeOOoster (vacuuffi)\Ii'amemounted){B cyl. Typical

CoOO/tiOO C"10U/900 C800/950 C600/850 C800/950 C600/850 C700/750

23 125 P-1480 23 129 p-1483 23 126 P-645 23 127 P-1481 23 131 P-42!5 23 132 P-4216 23 133 P-4217

----------

22 120

22 121 P-5261

22 :IT9 P-525S--

BRAKE &-C;o-;-LU"-;;-T"C-;-;H"-;;-P;-ED~A";-L"S-----------------L---------.L---L

~-BraKe-&C1Utch-!:)e(rals & related parts 1C-SO071100,CT750,7950- 24 149 1--P:'::330°

BRAKE MASTER CYLINDERS ~+----BraKemaSlerCYTmi:fer-=TYPICar--------------- C"fiOWITo-o,ci'7507f)50- -21 47-P:':-23-31--

. BRAKE SYSTEMS ------

-57/tiO Air brake system 1 0/

950 2-2--5: I 1'-2340--

~{ Air DraKe system (99", III" w/b)(8 cyl. 292) C550,7800 22 60 P-3884---61/63 Air brake system (99", 111" w /b)(S cyl. 302, 332) C550/800 22 6 ! p-3EISr-61/ Air brake system (99" & 111" w/b)(8 cyl. 401, 477, 534) C850/1100 22 61 1 P-3882 61/ Air brake system-rear section installation-l;J5", 15;J", 1"15" C600/I100 22 6rrp- 3883--

w Ib - Typical -6-2/ Air orake system-rear section installation-135", 153" wlb - ICT750/850

-- 22-~17J"'''88~-(8 cyl. 332, 401, 477,534) - Typical

ti2/ Air braKe system-rear section installation (135",153" w/b) - CT950 22 n j5:38-89--(8 cyl. 401, 477, 534) - Typical

22-ht:! 1 P-3SSO---62/ Air brake system-rear section installation (161" w/b)(8 cyl. CT750/950 332,401,477,534) - Typical I

63/ Air orake system-nand control valve --

'CT'i50/950 -- 22- l1iS-t--P-4T2-6--

59/60 Air brake system-Tractor Trailer ! c</OO/ 1100 22 '1~~=-29°38 61/ Air brake system-Tractor Trailer .C600/1100 22 77 P-3861 61/ Front brake air limiting valves C"1:>Uj 110U 22 102 I P-3871 til/ti;J Hydraul1c vacuum brake system with frame mounted vacuum C550/600 22 119 i p-5258

booster (6 cyl. 262 & 8 cyl. 292) - Typical I I.

til/tiJ Hydraul1C vacuum brake system with frame mounted vacuum C700/950 22 1.'7-5259 booster (8 cyl. 292,302,332.401,477) - Typical

63/ Hydraunc vacuum brake system with frame mounted vacuum C600/700 22 121 I P-5261 booster (Dagenham 6 cyl. 330 Diesel) - Typical

I 57/60 Hydraulic brake system (with vacuum booster) - Typical C550/950 22 55 P-2339

-

14 ILl.USTRATION

SECTION 10 'OR' TRUelt 'ARTS

YEAR I 19 __ TITLE

INDEX

C-CT SERIES IRAKE SYSTEMS - continued

63/66 Maxi air parking brake installation & Tractor Trailer Emer!(ency Air Supply

t);j( Maxi lllr parking brake tube installation with Eaton & Timken 17M, IBM rear axles

63/ Maxl :nr parking brake tube installation with Eaton & Timken 17M, 18M, 21M, 23M rear axles

"----...

IRAKE W.IEEL CYLINDERS

MODEL SECTION I PAGE I ILLUS. NO.

C600/1100,CT750/950 22 84 P-4552

C600/750 22 90 P-4553

C 8001 1100 22 91 P-4554

:'; 1 F<,iif1>"""-oyJCriileiCCT,p1Oil ICc50000799500 12211 ; ~4"66 i P-l~ 7 - Re~:~:~keCY_l_in_d_e_r_-_T_yp __ i_Ca_l __________________________ r __ 5 __ 7 __ 5 __________ -t _____ -r _____ + __ P __ -l_4_2_4 __ __

-------------------------+-------------+----+----~-------_-----L

DIESEL IRAKE VACUUM PUMPS

~~::~:l::i~U:

tr~ BrakE vacuu-m----

_ MeC~~~!~

-- FRO-NT GI1dREAR BRAKES

pump & crankcase ventilation pump with C600/700 22 106 P-3925 vernor (6 cyl. 330 Dagenham Diesel)

pump&criUikCase ventilation pump with C600/700 22 107 P-4532 vernor (6 cyl. 330 Dagenham Diesel) - Typical

-------

WIT Front and rearcam airo~ Typical C55071l00,CT7507950 21 44 P-2062 5~ Front brake - Typical C550/700 21 42 P-3718 61/ Front brake (14" x 2 1/2") - Typical C700 21 42 P-3718 57/ Rear 6I'iilre jCooO/600 21 42 P-;s7l9 07/ Rear brake (lo' x 4 1/2") - Typical C700 21 42 P-3719 57; Front brake (double anchor type) C700;900 21 43 P-2063 571 Rear brake (except 15" x 4 1/2") C700 21 43 P-2064 57~ __ Rear brake - Typlcal C700/900 21 43 P-2064

--------- -" .~--------

-------

PARKING BRAKES -S7758 ~lng brake system - Typlcal C~oU/\:IOU 26 108 P-2320 os-r- ---parKlng orake {mternal sho~{l2" x 4'1 CtsOO/llOO 26 154 P-2847

.~ parkLng braKe system - mternal type - TYPlCal C~:>U~ 110u,CT'~900 26 lou P-3230 O!l/ park_ng braKe (mternal ShOW) (!I " x 2" &. \:I" x 3") 1t;:>:>U/ts:>O 26 1:>4 1>-2848 61/ ParkLng brake system for Warner 4 speed trans. & Clal'k 5 C550/1100 26 165 P-3596

speec_ MID, HID trans. 611 Parking brake system for Fuller Roadranger,Spicer 5000 & C750/1100,CT750/950 26 166 P-3597

6000 series & Transmatic trans. 62/ ____ !,arkin!br,,-k~~ t:>~ett~ir Chamber-rear wheel (Maxibrake) C600/1000, CT750/950 21 49 P-4131

---- ~-

----_.-

IC550/1100 I 14 38 I P-5322

I I I ___________________ -'-I _______ ---+-I_---+-___ L.I ___ _

-------------------------------------------+-------------+----+----r--------

YEAR 19~

TITLE

FtlRD TRUCK "ARTS

INDEX

E SERIES

MO DEL

IllUSTRATION SECTION 10

I SECTION I PAGE I

15

ILLUS. NO.

BRAKE MASTER CYLlNDE_R_S~~~ __ ~ __ ~~ _____ ,.~ ____ ~~~_ 6ITT~e masfercylinder] E100

8RAKE SYSTEMS 61) 631 Hydraulic brake system 1 ElOO

BRAKE WHEEL CYLINDERS ---Frontbi'iil{e-cylfiic!€r-:'-Typlcal

""7--r-+- Rear brake cyIinaer - 'l'ypical FRONT and REAR BRAKES

~7300--~-------h1ElOO/300 .

22 50 1 P-3384

.1 21 [ 21

61)631 Front & rear brakes ·--~-SPA"RE W·HEEL CARRIERS

.~ _________ --,-I E_l_O_O _____ .-.L._2_1---L1~~:3370 _

~ _ Spare wheel carrier & lock kit installation WHEEL, HUBS and DRUMS

tll/ Front wheel parts-TypIcal 61/ HiiOcap liiiawneeicover-::Rerer to Text Group 1130-

F SERIES

62/

I E100 14 34 -r-P-3wr-

ElOO 10 22 N381 IElOO

23 P-2337 23 P-2338 23 P-2338 23 P-1480 23 P-1483 2.3' P-645 23 P-1481 23 P-4143 23 P-4215 23 P-4216 Z3 P-4217

58/60 Air brake system (8 cyl. 401, 477, 534) . jF800/1100 22 [59 P-2957 61/ Air brake system-front section installation (8 cyl. 292) F600/750 22 I 67 --P-3S7:r--61/63 Air brake system-front section installation (8 cyl. 302, 332) F600/750 22 I 67 P-3874 61/ Air brake system (less compressor) F75OjllOO 22 1 62 P-3876 6!C. __ Air brake system-rear section installation - Typical F600/750 22 i 68 P:-:3875--~ Air brake system-Tractor Trailer F700TUOO 22 ,74 P-2923~-co21 -xIrorake system-Tractor Trailer F600/750 22 1 ~ p-T860--" ~2 Air brake system-Tractor Trailer FliOO/95a 22 '76 "P-3860--637- -- Air brake system-Tractor Traile·"'r'(.,.,-Sc..,.y'l...." 40)"'---1:, 4TIl'7"':7',"""-534n-)---kF800/11aO 22 1 81 -r--P-:'4124--.61/63 ----rurOi'aKe-system-compressormstalIafioil{8" cyl.~ F800 22 98 --+-i>:-3865"--W-+---AIi'oriike-syslem-cOmpressor-insliiIra1Ion (llCy~477, 534) F!l507T~ f---~2 19 8"-- !---P~3-866 ---'-GITu -----arr7liYarauIic brake system\lfCyI~l, 477} - Typical F800/950 22 : 113 . --P-52~-­

f-------------- ----r--- -------

16

YEAR 19 __

ILLUSTRATION SECTION 10

TIT L E

F'RD TRUCK 'ARTS

INDEX

F SERIES

Maxi aIr par ng ra e tu e ins a ation with Eaton 17M, 18M, 21M, 23M rear axles Maxla~KIng brake installation ::-t'ypic

BRAKE WHEEL CYLINDERS

MODEL

07;-- ------FionfbraKe cy1inder:';-TyPicaT'- --- I ,n uu 7900 -577-- --Rear brake cylinder - Typical FIOO/950

FRONT and REAR BRAKES -;)1T--~-~ont and rear cam air bra"k:==e-::;s---Tm:::yp::-;iC::c='al~-------- FtiOO/ nOO

57/63 Front & rear Dral<eS - Typical FlOO 57/ Front & rear brakes - Typical F250/350 57/ Front brake - Typical F500/750 61! Front brake (14" x,Z l/Z") - Typical F700 571 Front brake (double anchor type) F700/950 5'7{ Rear brake (except 10" x 4 1;'2") F700

SECTION I PAGE I

22

22 22 22

22

22

22

ILLUS, NO,

P-5237 P-5248

P-5263

P-5243 P-3870 P-4550

P-4~

P-45-54--

P-4~

21 '46-------p-=-n2~ ----

21 46 p-1424

21 44 1>-2062 21 40 P-678 21 41 P-1544 21 42 P-3718 21 42 P-3718 21 43 P-2063 21 43 P-2064 21 43 P-2064 21 42 P-3719 21 42 P-3719

PARKING BRAKES ------------------"----------~------'-----'---~----

07/0tl parking brake - TypIcaL FoOO/700 26 152 P-1414

~~~~-Parklng DraKe - Typical F'IOU/900 26 10J P-141ti

C----parklligbrake system - Typical FIOO/250 r--26- 150--P--2319--

57= --PaflUng brake system - transmission mounted F~O ---'26- 168--p--=53n--

~ r-----Parlililgbiah?-(inte rnarsnoe T\I2"X4") FtlOO/llOO 26 154 P-~847-

~8j'titi ParKing brake system - internal type - Typical F500/800 26 159 P-3229 5~ ParlUng brake (internal shoe)(9" x 2" & 9" x 3") F350/850 26 154 P-2848 -sI!El6 Parking braKe system - Typical FIOO/200 26 167 P-4S67 62769J __ Par lUng bra¥e&ralety Air Chamber-rear wheel jMaxibrak!1 F800/1000 21 49 P-4131 63/69 Par lUng brake (spicer auxiliary trans. 7U41) F950/1100 71 404 j:i=4~--

SPARE WHEEL CARRIERS 57!~ Spare wheel carrier (flare side) F100/250 14 35 P-2662---

57/ Spare wheel carrier (flare side) F350 14 35 P-2603

57/. Spare wheel carrier jstyle side)_ FIO<l[350 14 36 P-2604 M/--r- --Spare -wneef carrfer (frame moUritea) FlOO/350 --~ -3"7- -P::5321---

1----- - .. ---- ------5'1/- --- -Sparewneercarrfer(rrame mounted) F500/Iloo 14 3'8- P-5322

FORD TRUC/( flARTS

INDEX

TIT L E

F SERIES

MOD EL

ILLUSTRATION SECTION 10

I SECTION I PAGE I

17

ILLUS, NO,

---W.rEELS, HUBS and DRUMS

~ 57[ 571 57[ ';HI

5~60

"5'7/ ~

~~j~ ""61/-'57760 07/-till

o'~ ""61/' '57T-W69 W69 07/

61/66 6:J/titi

-~yronT wneel pai-15 - Typical 'FWO 10 ;::;:: P-I381 Front wheel parts F250;'350 10 22 P-1382 Front wheel parts F500 10 23 P-2004 Front wheel parts F600 10 23 P-2005 Front w1i.eeyPartS-Uuar-iear wlieel - Typical F:JoU 10 ;::0 P-2003 Fronf wlieelparfii::arscrype (tubeless tires) - TYPlcal F70079-SU- 10 ;::4 p-205-2 --FrontwlieeIparfs-:arsC1ype ~Kioe £Ires) - Typlcal IF7UUj700 10 :Jl P-I39~0--

C---"Fron1wneeT parts - dlsc type (tube tireS) - TYPlcal IF7~U 10 :J;:: p-1387 ~mwneel parts - dISctype\fiiOetires) - Typlcal F:Jou 10 :J;:: P-1384

c--Promwlieel parts--::-alscType\tUbe tlres) - Typlcal FoU078"Oo- 10 31 P-649--'---Vront"wI1ee!parts - disctype:l,M tnru 10M !ront axles - Typlca FS"00lII00 10 26 P-3023-~

-""FrontWlieeTparts-spoKe type (tubeless friesr=-TYPlcal 1.t!'tiUO/tiOU 10 :t4 P;:2051 ---ViontwneeTP"afts-;; spoke-type (tUoe tlreS)-Typlcal 1.t!"luuj"lou 10 33 P-ITSO-~iO'nTwlieel parts ;;;Sp0Ke-fype-tiM tnru 10M lront axles - 1.t!'tiUUI !lUU 10 :tti p-352-;r-

Typical Fioiifwneerpaifs.:-spoket'YPe-{tuoe tireS) - TYPICal IYIO~\lOU 10 :J:J P-U8S-

r' -Viont wlieel drive liUbloCk parts (Dana) 1.!<'lUu..;,:tOU ~X4) 10 :tl P-'4366 i-----rfear-dUalwheeTl)arts:'dl'sc-type (tubeless tIreS) - TYPIcal F;JoU 10 ;::8 p-2474-

Rear wheer'parts-spoketype--- 1.t!'tiUU/tiOU 10 :tts p-2053 Rear wlieel parts - spoKet'ype ~tube hreS) - TypIcal

--~~7~~~o- 10 :to P-l186 r---Hu.o'cap-ana"\vlieeICc:iver-'::1teIeito Text Group U30 -----

H. HT SERIES BRAKE SYSTEMS ----AIi'lJraKesy5lr.e:-::m""('r.lec::s"'s...,c:c:o'-::m'"pc:":rO":ec::sc::s""'o='r)--_"T"'yp""IC-:=.r-------'".""""""""'.,.-----,.- ...,""---,-",.--T----.p"_, 3"'88"'5~-

'-AIr braKe'System (less compressor)(HendrickSon&RockWell P-38~ Standard Lightweight Suspension) - Typical

-Air ra e sys em compressor insta ation P-3867 P-3868

~~~~~~----------~--~~~~~~--~--+-~--~=--+~P~-~87---

P-3872 P-4554

22 p-4555

22 P-4561

22 p~4571

22 P-4559

0 22 P-4558

22 8 P-4560

22 88 P-4557

Hendrickson suspension FRONT and REAR BRAKES

Front and rear cam air orakes - Typical H-HT850/1000 21 44 P-2062 Front & rear Stopmaster (Rockwell Standard)-air brakes - H1000, HT950 21 45 p-4115 w/manual & automatic adjusters-Standard & Failsafe air chambers

18 ILLUSTRATION SECTION 10

FIJRD TRUCK flARTS

INDEX

T I TL E

H-HT SERIES

N - NT SERIES BRAKE AIR CHAMBER

"S"'2"j-'[--p""'arKl'ngorake'Esa:retyair chamber-rear wheel (Maxibrake) BRAKE BOOSTERS

MOD EL

[ N-NT850j950

63/67 Brake booster (vacuum)(dash mounted)(Midland-Ross) and frame N500/700 mounted reservoir installation

0:1/07 Brake booster (vaCuum)(1rame mounted)(Bendix li 1/ li" & NoOO/700 10 1/4" diaphragm type) & reservoir installation-Gas & Diesel

0:1/09 Brake boosteI'\air /hydraulic)(frame mounted) and air N600/750 reservoir installation

63/69 Brake booster (vacuum -an<raIi'J\fi'ame mounted) - Typical NlStlO/9tlu 63/69 Brake booster (vacuum)(frame mounted) and reservoir tanKS - NlStlO/9tlO

Typical 63/69 Bra"KeooOSferlframe mounted dual vacuum) - Typical NTlitlU

I N-NT500jll00

compressor

Hy rau ic vacuum ra e sys em 1)3"/69 '-'HydrauliC -vacuumor'aKe'sysrem- - -,---, W{69 ,- -Hydraulic-vacuum' iii,r-air !liyarauriC-praKe' system - Typica 637()9 --Maic'faJTljailillig oraIre-insfalIation-:.'Typicar-------TIf<>1:C.,.,-rn

~ -'--MaxI' airparkingor'aI{einstallafioii&TraCtor Trailer Emergency Air Supply 'MaXI'ali' parKingor-a:ke'TubeTriSfalIaTwii'with Eaton & Timken 17M & IBM rear axles

ILLUS. NO.

SECTION I PAGE I

P-3498 P-3499

P-3500

P-35m-

21 71

10 10

21 49 P-4131

23 130 P-4143 23 131 P-4215 23 132 P-4216

133 P-4217 3 134 P-4218

23 137 P-4161

23 138 P-4162

23 143 P-5254

23 144 P-5255 23 145 P-5256

23 146 P-5257

24 151 P-35~

22 96 P-4 21

22 94 P-4116 22 94 P-4116 22 95 P-4117 22 96 P-4118 22 97 P-412~2-~

22 98 P:'38~-

22 104 P-4f'2S'--22 80 p~4123--

22 116 P-5251 22 117 "P-5252--

22 1f8 P-5203-22 92 P4551-'-

22 89 P-4550--

22 90 p-:"4'553--

22 91 P-4554--~~rl--~ ,~~~~~~~~~~~~~~~~-~~~~----4-~-~~-+-n~~

22 93 P-4555

'tlIlD TIlUCI( IIAITS ILLUSTRATION SECTION 10

YEAR 19_

TITLE

INDEX

N. NT SERIES --BRAKE WHUL CYLINDERS

57/ 57/

63/69 07/ti9 til/ti\!

63/69 63/69

57/ 63/

57; 57/

Front brake cylinder - TypiCal Rearorake -cylinder - Typical

._------

Bra e vacuum pump crankcase venti ation pump wit Mechanical Governor (6 cyl. 330 Dagenham Diesel) - Typical

FRONT and REAR BRAKES Front and rear cam air brakes - Typical Rear oraKe (10" x '.I 1/2") - Typical Front brake (14" x 2 1/2") - Typical

SPARE WHEEL CARRIERS

WHEELS, HUBS and DRUMS Front wheel-disc type-6M thru 15M front axles - Typical Front wheel-spoke type-6M thru 15M front axles - Typical

P SERIES

BRAKE BOOSTER INSTALLATION Brake booster(vacuum)(frame mounted)(Gas) Brake booster (vacuumJ\frame mounted)(Diesel)

BRAKE WHEEL CYLINDERS Front brake cylinder - Typical Rear brake cylinder - Typical

MODEL SECTION I PAGE I

N500/950,NT850 21 46 NoOO/950, NT850 21 46

N600/1100,NT850/950 21 44 N700 21 42 N700 21 42

26 154 21 49 71 26

26

26 26

26 26

26 175

N600/1100,NT850/950 10 26 N60~,,1100,NT850/950 10 26

23 124 23 125 23 130

I P350/500 I 23 139 I IP350/500 I 23 140 I I I I

P100/500 21 46 P100/500 21 46

19

ILLUS. NO.

P-1423 P-1424

P-4532

P-2062 P-3719 P-3718

P-2848 P-4131

P-5739

P-5322

P-3523 P-3524

P-2338 P- 480 P-4 43

P-5241 P-5242

P-1423 P-1424

20

YEAR! 19 _'

ILLUSTRATION SECTION 10

TIT L E

DIESEL BRAKE VACUUM PUMPS

FORD TRUCK 'ARTS

INDEX

P SERIES

63l~-61-- -Br-akevacuum-pump&- crankcaseveIitilation pump with

MOD EL ILLUS. NO.

SECTION I PAGE I

Mechanical Governor (4 cyl. 2M Dagenham Diesel) - Typical -----J- - ------- ----------------1------ -----I------I----t-------

FRONT and REAR BRAKES 57/ Front & rear brakes - Typical P3507400 21 41 P-1544 57/ -~F~r~o~nt~bh,r~a~k~e~-~T~yp~i~c~al,-~--------------hp~5~0~0~~-----+~21~~~4~2~4-~P~-3~7~1~8~-_57/ Rear brake - Typical P500 21 42 P-3719

------ ------ ----1----------- ---f-------

-------- - ----- ----------- - -----1---------

PARKING BRAKES 577 I Parking brake system P350 26 155 P-2319 6(),i67 Parking brake system - Typical P100 26 155 P-2319 57{ Parking brake system (with 3 speed M/D & H/D trans. ) P350/500 26 156 P-2318 57/ Parking brake-Orscheln (with 3 speed H/D & 4 speed trans.) - P350/500 26 157 P-2342

Typical 59/ Parking brake (internal shoe)(9" x 2" & 9" x 3") P3507500 26 154 P-2848

- ------------_._---- -------- -----~--- --- ----- ------- ---

-- --------- ----- -- ------ ---------- -------SPARE WHEEL CARRIERS

57766\ Spare-Wlieerca-rrierlffiime -mounted, rJ7T- - Spare wheel carrfer\Irame--mountea)

I ___ J WHEELS, HUBS and DRUMS

FllTu-- --- nFronlwheel parts=-aisc type\fuoeTfresr-=-Typical p~-- 10 3T--p-=-649--57T--ProntwIleefpartS-=-tTIllcal P3507400 -- 10 22 P~-1382--57T- ---Fronrwheefpaifs ~P-5~00~------ 10- i--z3-- -P:-20~

--S...,y- -Flub cap and wheel cover - Rerer-fcJ-TexCGrOu:pI~---- ]510-07500---s7T- - UReaI' dualwheer-parfs.:.aisc typT(Iuoeless tiI'e.s) ___ Typi<:.a~__ P~~0/500:-- 10 28 P-2474

- ----------- - --------- ----------- - ---- --- - ----- -

T SERIES BRAKE AIR CHAMBER

-62/ .-._i __ parklllg_b~ake ~Safet~~ ch~~be~-rear ~he~Q~~~ra~~-f~=5-o.-~~-~~~=lYl~-1_4=. _+~41_~---~

BRAKE BOOSTERS -57lO2-i--~ake booster (air) T700/950 23 129 P-1483 -57762 I BraKe booster (vacuum)(9 1/:;" Bendix piston type) - Typical T700 23 126 P-645 -57762·t-~ke booster (vacuum)(9 1/:;" Bendix tandem piston type) T7507850 23 128 P-1907 63 Brake booster (vacuumj(9 1/2" Bendix piston type) T700/850 23 131 P-4215

63769 1---BraKe booster (vacuumj(ll" Bendix diap~agl1~~>'Pe)(C;a~ __ 'T7~0/850 23 134 P-4218 - --- - - - -- - +- --- ---- -

I - -------------- ------ ------ --- -- ---- - --- ---

--- - ---------- - -__ L-__ --

BRAKE BOOSTER INSTALLATlO'-'N..c."..~-~-~~~------~77~21 EBrake vacuum booster, resE:rvoir, tubes & fittings -T7507850 __ ~3 61T __ Brake booster (vacuum and air)(frame mounted) - Typical T700/850 23 6I76'7 Brake booster (frame mounted dual vacuum) - Typical T700/850 23 - - --- ------ - ------------ ------ -- -------------- -----

---- ---- - - ---- - - +---- -- - - -- -----

135 P-1908 141 P-5249 142 P-5250 ---- --

-- BRAKE-and CLUTCH PEDALS 57/60 Brake & clutch pedals & related parts

BRAKE MASTER CYLINDERS

_57/66j--- ~r~ke master CYlind~r -~TYPi::_-- -~_-_-___ --_~_~:-__ -_===_-_ 1'_7_0_6/ _~_O~-_-_-_=_-_--_

--------- -- --

P-2325

FDIlD TIlUe/( PAIlTS ILLUSTRATION SECTION 10

21

INDEX

YEAR I 19. _,

TIT L E MO LJ EL I SECTION PAGE I ILLUS. NO.

T SERIES ------- -

BRAKE SYSTEMS 57/60 Air brake system (ll cyl. 272, 2n, :5U2, JJ2) T7UOjllOO 22

58/60 Air braKe system (8 cyI. 'lUi, 'In, GJ'I) T750j9~0 22 61/63 Air brake system compressor installation (8 cyl. 302, 332) T7007800 22

6J769 --Air DraKe system compressor installation (8 cyl. 401, 47'1,534) T850j950 22 -wog Air brake system (less compressor) TI00j9GO 22 6:5/69 Air Drake system (less compressor)-176", 194",212" w/b-with TllOOjll~O

+-:2 Timken SLDD & SQDD axles 6I7TI9 ~ir brake system-hand control valve T700j950 22 61/65 Air7hydraulic Drake system (158",1'16",194" w7b) T700 22 59760 Air Drake system-Tractor Trailer T700j950 22 ~

-- Air Drake system-Tractor Trailer T750j950 22 63/69 Air br'_ake~ys_t~I1l_=Tractor'I'rail~r'J8 cyl. 401, 477,534) ~~~~~- 22

""03.709 I-----Arr oraKe tube instarration with Timken SLDD, S"QDD, SRDD, ---~--. --22-SUDD & SFDD axles

61/69 Front brake air limiting valves T700j9~0 22 57/60 Hydraulic brake system - Typical T700jlloO 22

6f,76:r Hydraulic vacuum Drake system T700jll50 22 63/69 Maxi air parking brake installation & Tractor-Trailer T700j950 22

Emergency Air Supply 63/69 Maxi air parking brake tube installation with Eaton JOD, J4D, TllOO/950 2i-

34M, 38D & Timken SLHD & SQHD re;'lr axles ==+ ---- --- ----------------- ~----------=--t~~ ------- - - "-- --_._------ ----------

58 ~-P

59 P 98--

::26<fs-­=29"57-­=-38~ -3866-

I-p

98 63 66

P P::3877-­p~~-r

103'- P::387-3-­~52~·

-29:f3--114 74 76 81

--82

101 54 112 89

f-p

P P

t~ -~386-0--

-4124 -4556

I--p -=38~

I

-=1906--P P P

':::;244 -­

-4550

~_..l 93 i P -4555

I ----- t --

-Tiio6~--·-- -------- _.--P'::20 57/ Front and rear cam air brakes - Typical 21

57/66 Front brake - Typical T700 21 57/69 Front brake (double anchor type) T700j950 21 57/66 Rear brake - Typical T700 21 57/66 Rear brake (15" x 4 1/2") - Typical T700 21 57/66 Rear brake (except 15" x 4 1/2") T'IOO 2i 57/69 Rear brake - Typical T700/950 21

PARKING BRAKES

44 42 43 42 42 43 43

i 62 18-~-37

--63--i P-20

I P-37 . P-37

19-19--64--IP-20

t_ P- 2O 64

i

57/58 Parking brake - Typical T700 26 152 P-1414 57/58 Parking brake - Typical T700/950 26 153 I p-1416 58/66 Parking brake system - internal type - Typical T700/800 26 159! P-322-9--58/69 Parking brake (internal shoe)(12" x 4") T750/950 26 154 I P-2847--59/69 Parking brake (internal shoe)(9" x 2" & 9" x 3") T700/850 26 154. P-2848

"6"'27F./69,.-+-------,p"-a=-=r::'Cki"'· n::-:g::--Cb=-ra;:-'kCe:-7,-&'S'i"::)af-:T::,et"'y:-A-'--;-:ir~C"'h-=-a"CCmCLbC::e-=r---C-r:::Ce:-::a:-::r:-Cw:::rhe::-e:-'l---C("lM~ax=iLbr:C-a"k-:-:eT) --+'T"'8""50oC) /"9"'5""0:-------+ 21 49 1 p,::-!~ _~3!69 ~ ____ -~I>arkiIlfS brake \Sr>icer auxiliar~traIls.:IU~:~ _______ ni~O/~~~ _____ 71_ _454

n

LP-4063--

_-~=.._.;_---;-;-;-;;;-;;-------.=~---------1-'-------......Lt---....L....---- ~ __ n --_

~~~WHEELS, HUBS and DRUMS -Front wheeTparts-discTyPe-OM thri.lI51\1:rront axles - Typical

~:"""".-I---~F~r-o.ii.tWheel parts=spoKe typ€lfiiOeleSs tires - Typica Front wlieeJ:pa-rts-disc rype {[we ess ires - Typica

-----pronfwneel·parts-spoke-type=-f)KI"thru 15M front axles-Typical HuocapanaWlieeTcover-': -Refer to Text Group lI30

-""'-rmorl---~R~ear WheeT parts-spoKe type-. Frontwneelparts-discty'pe (fiibe tires) -'=--Typic 10-

~~,rl.-----Yront-wlieel paits-=-clisc-fype-(tuDeTIr€s) - Typical ------Ir-m,.""""-=""------·--+-<l""O--f---o Fr-<int-wneeTiJans-spoKe type(fuoe Ures)-~--------h 10-

-FroiU-wneelparts-spOKe tyPe (tUDe tiresj-Typical 10 - Rea:r-Wheerpa:rrs:-sP0KeType(tU'5ef[res)'-=-'TT~yp=lc;;a:rI------t-"f7"Cl'''''",",,- 10

---j--------'-----=------'--'-----'-------'---=-=-------+----"-------+---=-=--I----=~-.--I----------

22 FDRD TRUC/( PARTS

FRONTW HEEL PART 1957 / E-F1~0- TYPICAL

1216

72054-5

354573-S (MM-64l

FRONT WHEEL PA 1957/ F250/350 RpTS - TYPICAL

, 350/400

P-1382

1120-'.H.' f 1121-L.H·Y

1015

1015

FORD TRUCI( PARTS ILLUSTRATION SECTION 10

1125

1190

4221 'k\ ~"04_"02 ~"

,'0' ~ '~~',~I~ ~ ~i~"1216

1195

351152-5 (MM.98)

FRONT WHEEL PARTS 1957/ B-F-P500

1

72053-5(N.52) ~ 1131 "1 ~~

~i~ 1216 1195

351152-5 (MM.98)

FRONT WHEEL PARTS 1957/ B-F600

"f'r1107_R.H. l.110S-L.H.

11

{1107-R.H.

110S-L.H.

23

357594·$ (BB.401)

P·2004

351505·$

"'(1 357594·$ (BB.401)

P·2005

24

120-R.H. h 121-L.H. J

®

356085-5 'lr 1042

ILLUSTRATION SECTION 10

FORD TRUCK flARTS

I

~~ 34809-S (X-68)

33846-S (M-69)

FRONT WHEEL PARTS - DISC TYPE (TUBELESS TIRES) - TYPICAL 1957/60 B700/750, C550/950, F-T700/950

L----3'180/,_S (X-64)

L------20310·S (8-48)

1014

FRONT WHEEL PARTS - SPOKE TYPE (TUBELESS TIRES) - TYPICAL 1957/60 C700/850, F800/850, T750/800

7 20453·S (8-200)

OR 358688-S

lUU-118)

P·2052

-5 OR 358688·S (UU-118)

P-2051

1120_R.H.! 1121-L.H.

356085-5 (MM.14)

5

1020

FORD TRUC/( PARTS

34424-5 (M-84)

72292-5 IN-761

72072-5 (1'1-62) 1216 1217

," 1131 1195

354573-5 (MM-64)

1104

ILLUSTRATION SECTION 10

11Of-itH. 1108-L.H.

FRONT WHEEL PARTS - DUAL REAR WHEEL - TYPICAL 1957/ F350

REAR WHEEL PARTS - SPOKE TYPE (TUBE TIRES) - TYPICAL 1957/ F800/950,T700/950

25

P-2003

P-1186

26 ILLUSTRATION SECTION 10

FORD TRUCK 'ARTS

351163-S (MM-S. 2)~ 72089-S IN-55)

1131--i1~ J-1~~ ____ \

6000 LB. :

~1195 I 1131~~ r72089-S(N-55)1

34806-S(X-64) ~ _____ , :

2gm)-S~~ • ~351163-S ~ 1

1015

1153 7000 LB. IMM-S2) : :

1 1 1 1 1 I 1 1 1 1

1217

1 1 -1-- ----

1 1

i, l-S (:~;:j 1

1

1104

1

1 1 33846-S (M-69)' ~

34809-5 IX-6S) ~ (u-

::~l:~:~rf1Q"'Ib'~"~'---(X-62) ,..\"-f l' 3293

20310-S 1131 3276 (8-48) 1153

9000 -11 000 & 15000 LB.

1125

*U5ED WITH 15000 LB. CAPACITY FRONT AXLE ONLY

FRONT WfIEEL PARTS - DISC TYPE - 6M THRU 15M FRONT AXLES - TYPICAL 1961/ B6DD /750., C55D /110.0., CT75D/95D, F6DD/11DD, N6DD /110.0., NT85D /950., T7DD/95D

351163-5 (MM-S2) V-- 72089-5 (N-55)

1131 ~£1 if_1~~_ --_'I

6000 LB. :

1131 If-- 72089-5 (N-55)

~~llf1195 I

34806-5(X-64) 'h-----, : 2°i.W-5~~ • 351163-5~ 1 () 1153 7000 LB (MM-S2) 1 1358671-5

• 1 1 (WW-62)

1042 : lJ1217 J 1 I OR tl ~ 1 4222 til

1 1 356085-5 (MM-14) --1-- ---

1 1 ,min 1 1 ;:r;:;

:>-'-'~~ 11216.1 1

1

1

1

1

1014

\ \

\ \

1

26483-S 1

'~~Q' :··~'b"~·--j 33846-S(M-69);tJj- --"

34809-S(X-6S)Y

~ 3276 3293 1131

1153

1125

*USED WITH 15000 LB. CAPACITY FRONT AXLE ONLY

(I-nB)

P-3523

9000-11000 & 15000 LB. P-3524 FRONT WHEEL PARTS - SPOKE TYPE - 6M THRU 15M FRONT AXLES - TYPICAL 1961/ B6D0/75D, C55D/11DD, CT75D/95D, F6DD/11DO, N6DD/llDD, NT85D/95D, T7DD/95D

'Ti

~ Z >'l ::;:: ::z: I:':!

.... I:':! ",I:" ~t:;)

'-~ ::II:':! 0::z: °el ~tp 01:" ~O ""() >: ~ .e'd

;I> ::0 >'l 00

B ;I>

~

378390-S (BB·17·Y)

1961/ EXTERNAL TYPE HUB LOK

F 250 (3500 POUND AXLE)

1964 INTERNAL TYPE HUB LOK

F 100/250 (3000 POUND AXLE)

3219-R.H. 3220-L.H.

P-4366

.... Q • " ;I c:: ~ Z • ;::

-",I"" ml"" n C -t'" _-t O· Z~ 00

Z

l\:I -J

28 ILLUSTRATION FORD TRUC/( 'ARTS

1134-R.H.

1135-L.H. --/--

rOt 356085-S

(MM-14) or

1120

SECTION 10

1239

1132-R.H.

1124 t 33846-5 1001 b ~

(M-69) 1151 0 6i~J \ t . ~o~·~ \\~?~e '\ 1240

\ \ \ '\ 4252 \ ..... 1142 1181

34809-5 (X-68)

1126

REAR DUAL WHEEL PARTS - DISC TYPE (TUBELESS TIRES) - TYPICAL 1957/ F350, P350/500

REAR WHEEL PARTS - SPOKE TYPE 1957/ C800/850, F800/850, T750/850

P-2474

34811-S 350724-S (X-71) (88-201)

P-2053

FORD TRUCK PARTS ILLUSTRATION SECTION 10

1109 1247

4222 1246 l ~ l~~ ~~(Q)~ (~ 1 1175

12M 1M9

1126

"-4255 ~ -, - 1244

34806-5(X-64) 42t 1 ~(Ill *304790-5 FRONT

i QW8\@) + :,*351174-5 -~ t 1240 - ~ --------------- ' T(tl 1124 ~354463-5! ~ \ / (1 1183 358671-5 ~ I

20326-5\ 1248 \WW-62)-- 737 ./ (B-49) ~ ____________ ----->l<1 044

203

l26-5 (B-49) 4252 42C 12480~~~1 ~

(\0 t 1124 ~-\ \ 1183 _ ~ 4340

\ 34806-5 (X-64)----------',-- ----1- 5

*U5ED WHEN "V" BELT DRIVE 15 NOT INSTALLED

4740

~

CAST TYPE

, FRONT

~

4737

DISC TYPE

REAR WHEELS, PULLEY & BELTS - PAGE & PAGE SUSPENSION 1961/ HT850/950

29

P-3535

::0 tx:I

~ :;:: :z: tx:I tx:I t"' u.> ~

tJj

~ u.>

"d ;J> o tx:I ~

~ ~ ~o '-tx:I

~ :z: u.> ..., "d ""tx:I ~~ ~o ~:z:

.... "" il:: "%j o ~ ;J>

~ ::0

~ 8

~ ~ t"' tx:I

1175

1249

JJ.... ... . 1247 I

1246 ) DISC TYPE

1202

"" '! tl>\' i~ ,«~ :, 3""~~ ~ 31~.~~iS .• 0. ~Qt ... /~ ~~(x.7~ ......... 43~rf ~~.. .. 4255 ~ *354463·S / ~ r ...• 4252 3~:~~~iS CAST TYPE ~/~~

20326·S ~. ""'" ~ (8·49) 1248

~, 1 / f218-l.uf!~ I

\, "'453~(XX·"A~ "'--_/~~

2316·R.H. ~ - ~~ I \,,~ 2317.L.H. ~ 2A311"'~-

2036 -"

2341

1244

~ ~-

P·3551

w o

CIt;: .. r­n C -I'" --I 0-Z~ 00

Z

i ~ c:: ~ Z -~

1007

FORD TRUC/( PARTS

or

1195 1201

1125

ILLUSTRATION SECTION 10

1104

FRONT WHEEL PARTS - DISC TYPE (TUBE TIRES) - TYPICAL 1957/ B500/600, C550/600, F500/600, P500

1~~~~~~77)

31

(88-401)

P-649

119:J/~

~~,~,~,q~

1104

FRONT WHEEL PARTS - DISC TYPE (TUBE TIRES) - TYPICAL 1957/ B700/750, F700/750, T700

20453-S (8-200) OR

358688-S(UU-IIB)

P-1390

32

1120-R.H. ,--

1121-L.H·Y

ILLUSTRATION SECTION 10

1007 --___ ____

FORD TRUC/( PARTS

72072-5 (N-62) 1216 1217

iT" .. 354573_5 (MM-64)

34424-5 (M-84)

FRONT WHEEL PARTS - DISC TYPE (TUBE TIRES) - TYPICAL 1957/ F350

1195 72089-$ (N-55)

351163-~ (MM-82)

113~ "

~[O1216 121

1153 34806-5 (X-64)

20310-5 (8-48)

1118

I

~ ~0:~(X_68) L ~~:46-$ (M-69)

FRONT WHEEL PARTS - DISC TYPE (TUBE TIRES) 1957/ C750/950, F750/950, T750/950

1202 OR

4222

1125

P-1384

1190

~ 7

358688-S (UU-118)

P-1387

FORD TRUC/( 'ARTS

1202 OR

1217

1014

ILLUSTRATION SECTION 10

1099

''''8S-S(~- '" '04' 7 '02' \J ~

FRONT WHEEL PARTS - SPOKE TYPE (TUBE TIRES) - TYPICAL 1957/ B700/750, F700/750, T700

1020

L--~34806-S (X.64) L----'20310-S(B.<I8)

1014

P-1lS8

FRONT WHEEL PARTS - SPOKE TYPE (TUBE TIRES) - TYPICAL 1957/ C750/950, F750/950, T750/950

33

P-1185

34

1386

ILLUSTRATION SECTION 14

FORD TRUC/( IIARTS

MODEL 891 P-3707

SPARE WHEEL CARRIER & LOCK KIT INSTALLATION 1961/ E100

1012

SPARE WHEEL CARRIER (FLARE SIDE) 1957/ F100/250

34806-5 (X·64)

SPARE WHEEL CARRIER (FLARE SIDE) 1957/ - F350

ILLUSTRATION SECTION 14

426·5 (8.32)

0"'--1413

P.2602

c...-""723468-5 (B·5)

35

P-2603

36 ILLUSTRATION SECTION 14 FORD TRUC/( PARTS

33798-5(M-62)

34806-5 (X-64)*1458

1453 (1957/63)

34805-5, (8-156) (X-62) : @

33795-5 ~ "'~_~_ (M-49) ""-"..~ , / ---~~ ~ -

34809_5 (X-68) / JG ""'~=w,

33846-s{"·~:o: {j . 20347_5 _'='" .~,

(8-156) I

34806Y: (X-64~

33798-5 (M-62)

44735-5 (X_32)

SPARE WHEEL CARRIER (STYLE SIDE) 1957/ Fl00/350

1474 1012

P-2604

FORD TRUCK 'ARTS

.1497

34449-5 --,,~_'" (M-S5) .... ···

: ............ .,;. ..... :: .... :: .. .

ILLUSTRATION SECTION 14

1408

37

.. -;.,

.......

-~~~~: -------j:,.,;!"S 5005 '\'~\!\ .. ,./ 1957/60 F350, P400-STANDARD PRODUCTION

, .. ,~ .. '

/:=:;;~:~ 'lO.~SO, P3SO~~PlCAL 1963/65 P400-SINGLE REAR WHEELS

1471

"­ FRONT

~

.1497

.. , ~~ '\ '\.,__ ----".:-' + " 44735-5~

1476 NUT"',...... 1443 ............ J (X_32~' 3~~;11;5 L.W. • .. -.... ·--------_ .... ____ ..... --·-·-····· .. 1462 359820-5 F.W. ,,'

(XX.2031 '

1961/64 F100/250, P350-TYPICAL *379673.5 .,

OR * 379684-5 '

34398·S

".

5005

.1497 33845.5

" (M.57) FRONT

359820-5 F.W. 5023 (XX.203)

1961/64 F350-STANDARD PRODUCTION .SERVICED ONLY ON P350

SPARE WHEEL CARRIER (FRAME MOUNTED) 1957/ F100/350,P350/400

1443

1965/ F100/250

-1408

P-5321

38 ILLUSTRATION SECTION 14

5005

1443---+.\it\;,jl.j

* 379684-5 ----0.[1 1453 BRACKET

* 73937-5 CLEVI5 PIN 72035-5 COTTER PIN

(101-51)

1966 P4oo-SINGLE REAR WHEELS

1471

1443

..••...•... 1476 .•...... / .:.:.:~~=-=-.:....::.::.::.J..::.::..::. "e

1961/ B-C-F-N 500/750-TYPICAL

FRONT-­--

* 1963/ IMPROVISE FROM ANGLE IRON

SPARE WHEEL CARRIER (FRAME MOUNTED)

,\11,'14-- * 3 79684-5

(!b._- 44735-5(X-32)

1471

~1476

C-F-N 750/1100-TYPICAL P-5322

1957/ B500/750, C550/1100, F500/1100, N500/1100, P350/500