GALAXY VM 160 kVA 2 module 1 +1 UPS with Modular Battery Cabinets

Sheet No. Component /Detail Description Draw ing Guide Galaxy VM 160 kVA 2 lvlodule 1 +1 UPS with lvlodular Battery cabinets- Drawing Guide

2 Solution Isometric & Runtime Olart Galaxy VM 160 kVA 2 lvlodule 1+1 UPS with lvlodular Battery cabinets- Solution Isometric

3-5 Solution General Arrangement Galaxy VM 160 kVA 2 lvlodule 1 +1 UPS with lvlodular Battery cabinets- Solution General Arrangements

6 Solution Anchoring Details Galaxy VM 160 kVA 2 lvlodule 1 +1 UPS with lvlodular Battery cabinets- Solution Anchoring Details

7-9 UPS (Sigle lvlodule) Internal views & Details Galaxy VM 160 kVA 2 lvlodule 1 +1 UPS with lvlodular Battery cabinets- UPS (Single) Internal views Details

10-12 UPS (Redundant lvlodule) Internal views & Details Galaxy VM 160 kVA 2 lvlodule 1+1 UPS with lvlodular Battery cabinets- UPS (Redundant) Internal v iews Details

13-14 UPS (Single/Redundant lvlodule) Interface Details Galaxy VM 160 kVA 2 lvlodule 1 +1 UPS with lvlodular Battery cabinets- UPS (Single/Redundant) Interface details

15-16 Wide-Battery cabinet Internal Views & Details Galaxy VM 160 kVA 2 lvlodule 1 +1 UPS with lvlodular Battery cabinets- Wide Battery cabinet Internal Details

17-18 Narrow -Battery cabinet Internal Views & Details Galaxy VM 160 kVA 2 lvlodule 1 +1 UPS with lvlodular Battery cabinets- Narrow Battery cabinet Internal Details

19-21 System One Line Diagram Galaxy VM 160 kVA 2 lvlodule 1 +1 UPS with lvlodular Battery cabinets- System One Line Diagram

SYMBOL

..L T

--(-)--

LEGEND

DESCRIPTION

EARTH

CIRCUIT BREAKER

BATTERY

BUSBARLINK

NORMALLY OPEN CONTACT

SYMBOL DESCRIPTION

CONVERTER

INVERTER

DC-DC CONVERTER

0 BYPASS SSW

----+>----- TERMINATION POINT

Scl)..11eider vElectric

~put: 4ellY AC llfiW~NGI[ MMNS l7llln11: GVM160KG6SMODB10R2 llV.o 2 imilI~l-'54e:.~ = r.tlHIS IJllMI Br: NNDDRA 10-SEP-15 ~NGLE

DIWllNG GUllE DQIER: c MIEISBf/1 oo 10-SEP-15 !'l«W;IKJ!j PmET: DRAWINGS ISIUJ 1 ~2 AflllRCMI) ff: M PAULSEN 10-SEP-15 N .A

NOTES:

PERFORATED AREA FOR AIR INTAKE

{TYP)

/ FRONT

1. INSTAL!ATION SHALL COMPLY WITH ALL APPLICABLE NATIONAL, STATE AND LOCAL CODES. EXTERNAL ISOMETRIC VIEW 2. REFER TO PRODUCT OOCUMENTAllON FOR ADDITIONAL DETAILS PRIOR TO INSTALLAllON AND SITE PREPARATION WORK.

63. IN AREAS WHERE SEISMIC PROTECllON IS REQUIRED, FOLLOW lHE INSTRUCTIONS IN GVM65KANCHORING-SA DRAWING.

64. FOR INSTALLAllON ON RAISED FLOOR, FOLLOW lHE INSTRUCTIONS IN GVM65KANCHORING-RF DRAWING

lHIS mAWNl NID SPEaFICA~ HEREIN N£ 1l£ PROPERlY OF SCHNEllER El..ECIRIC NID SHAU. NOT BE COPED. REPRODUCED OR

USED IN WHCl£ OR IN PART, NS lHE BASIS FOR 1l£ llANUFAC'l\H: OR SALE OF llEMS WITHOUT \Rl1tN PERMISSION FROM SCHNEllER

El..ECIRIC. llilS DRAWING IS BASED IJ'ON LATEST NMll.lilll.E llftRIATDI AN> IS SUlJECI" TO aw4GE Wl1HOUT NOTICE.

Scl}..oeider V"" Electric

RUNTIME CHART

Runtime Number of

Quantity & in

Battery Type of

Catridges Minutes

(GVMMBTU) Cabinet

6.7 10 lW

7.8 11 lW

8.8 12 lW

9.9 13 lW+lN

11 14 lW+lN

12 15 lW+lN

13 16 lW+lN

14.5 17 lW+lN

15.5 18 lW+lN

22.5 24 2W

30 30 2W+1N

38 36 3W

46 42 3W+lN

54 48 4W

62.5 54 4W+lN

71 60 SW

79.5 66 SW+lN

88.5 72 6W

97.5 78 6W+1N

105 84 7W 115 90 7W+1N

125 96 SW

LEGEND

lN = 1 Narrow Battery Cabinet:

SKU No. GVMMOOBCNS

lW = 1 Wide Battery Cabinet:

SKU No. GVMMOOBCWS

llll£: Galaxy W DIG NO: GVM 160KG65MQDB 1 OR2 Input: 480\I AC 3PH ~SINGLE M/>JNS

2 lllOUtNfiiiPS4B~ ~iAR ~~ CAB~EJS !MN Br: NAGENDRA 10-SEP-15 SOLUTION-ISOMETRIC VIEW & RUN'TIME CHART E11CHE1t C NllERSEN/1' 00 10-SEP-15

PRnECT: DRAWi NGS stm 2 Of2 f.fPRIMD Br: M PAULSEN 10-SEP-15

HIRD NGLE

PRWECml

112.74 [~134]

81.J8 c ...... ,J

JU1

I [!IM] & 1U2 27.48 2lil 21[~ - (.1119] (898] (600]- -QEIMICE MlllMlll SEJMCE

3.18'4-ll1IUM lllmJll' lllllWR Mmll!_ RB:IMDllED -~~ 1,,._.,_..._._.. llDUll IM1lElr ClaE-wmE-211. l'OIEll CllilljEf-2 l/O l'.MIE'-2 llllWR IWIER1' CllilljEf-.:-1A PIJIUI CA!mE-1 1/1) C:llllE'-1 [115't] I . . . l .t lOOll. !DE • • • • •• I

----DISRAY - - J - ~ ~ :.--;:;: 10

. CJ CJ CJ CJ CJ i:J CJ CJ - - - _.. -- ENMID-,,E'll)

c Ila - It""" ....... -------,._....-

\ Rlilllllll TX to/mt - - ] LJ - a 0 0

7 .56 - - - ;.1 [1970)

I I ~ [O . . l~

FllOHT - . . -------

- - J i:J - .,,Elll-ll (Elll.ARGED .,,EW)

- - - '\_-.c-(1lf;IR 10 IU-A)

- - ] ti - 0 - ~ -J.23

. . . . . I o •, ,• . ,· •, . • • 1• I • . ..

I * •, , • o I• •, . • • I. I • i~ I I I I I I

r - -.16 -~ C4r EBQt:lI ~~ EBQtfl -Ml~ [8116]

RIGHT SIDE VIEW

[[::?:: 0 ~OUlPUT

G ]] Floor Load ing Data

I EJ Weight in Floor Loading

SKU # Dimensions HxWxD in Inches (mm) lb (kg) on lbl'ft2 1ko.lm'1

OG-GVMPB160KG (Power Cabinet) 77.56x23.62x33.62 [1970x600x854) 1032 [469) 187 (915) OG-GVM1225KG65K I OG-GVMIPR225KG65K (110 Cabinet) I 77.56x 15.83Jc33 62 [1970x400x854J 483 (210) 125 (615) GVMSB160KG65S I GVMRB160KG65S (UPS) 77.56x39.45x33.62 (1970x1002x854] 1495 (679] 162 (793]

VIEW-A. !f.41MIC DIA.GRAM) GVMMODBCWS (Wide Battety Cabinet-Without Battet1es) 77.56x27.56x33.62 [1970x700x854) 482 [210] 72 [351) GVMMODBCNS (Namm Batteoy Cabinel-"11hout Batteries) 77.56x14.57x33 62 [1970x370x8541 306 [1391 90 [4401 GVMMODBCWS•12 GVMMBnJ I 77.56x27.56x33.62 [1970x700x8541 3630 [16501 564 [27601 GVMMOOBCNS+2 GVMMBnJ 77.56x14.57x 33.62 [1970x370x 854] 834 [379] 245 [1199]

E!lmlll!B alllBII rlRllnl Blllm r-MllI

D .i] NOITS: CEfll!ER OF GRAVllY 1. INSTAUATION SHAil COMPLY Willi ALL APPl..x:All..£ NATICWAI... STAlE AND LOCAL CODES.

Cabinet Center or Gnl\ity on Inches [mm

2. REFER 10 PRODUCT DOClllE~ATION FOR AlllllTIONAL IEAILS PRIOR 10 INSTJ.l..lATION AND SITE PREPARATION WORK. X-Dlstance Y-Oistance Z-Ostance 3. All DIMENSK>NS ~ IN INCHES [lllWMEIERS]. Power Cabinet 11.81 300 37 40 950 14 92 379

ill. 4. FRONT ACCESS REllURm FDR SERVICE. uo Cabinet 7.48 190 33.46 850 9.02 229 5. UPS:- INPUT POWER CABLE EHIRY IS FROM TOP OR BOTTOM OF THE !MIT. Wide Bauerv C8blne1 withOut Batteries 13.78 350 39.37 1000 15.75 400

11.A.TlERY CABINCT: CABLE E~ IS FROM SIDE OF l.tllT. Narrow Battery Cat>net without Battefies 7.28 185 39.37 1000 15.75 400 6. OPER.o\TING lIMPERAl\JRE: JTF TO 1 ~·F [ac TO 40'C]. x.:=..-1--1 z...::-_J____J 7. PROTB:llON ClASS: P2D (IP32 OP1IONM..). 8. COLOR: RAL 900J Wlf!E. .llllfl..llll -ill. 9. llHS ~FORMATION PllCMOES CIHiEIMTIVE CEJITTR Df GRAVllY

c.+LJ:UlATION. 1ttS DAfllllG NI> SP£CR\110NS l£RElt ME. lt£ PRCPER1Y OF 1JllE: Gci!axY VM • NO: GVM 160KG65MODB1 OR2 19.0 10. DOOR SWINGt FREELY Ral'ATES BY 1 BO'.

11. ALL DIMENSIONS EXCLIJJES SCRE.W PROJECllON OUTSIDE THE ENCLOSURE. SCltDlER ElfC1l.: Nf> SIW.l. Nar IE ID'EI, IE'RCllOCEll OR Sc~neider

ln~t 48lV /Ir. 31'11 D~t«ll N.&JNS 12. IS lK: llCOULAR 8ATlElff CABINET IS 11.A.'IED WITH POWER FRAME, USED .. lllllE DR It PART, /6 11£ llllllSIS ~ T1£ IWU'M:l\IE

2 Mlllll.E~utll'S~ ~ ~~ aetlEIS llllm!BI': JW:ENORA. 10-SEP-15 HIRD LEFT SIDE PANELS (C<MRS) OF THE l'OWER FIWllE WU. BE OR ~ ~ l1ElilS WIMM' WRIT1EN PEllllSSJN FROM SCltDlER Electric &J..lllllJH;ENEP.AL ARR.llaMEHT EllllER: C~lll 10-SEP-15 ANGLE TAKEN our ANO llOUtmll C»I LEFT SIDE OF RESPECIM: NARROW EllCTRIC. 1ltS OIWM.l IS Bl\SED tFON LA1ES1' AWAll.E D•=<W f'>OIUET N'a!IM'IK»t NI> JS SL8ECT TO CHANGE 'MM>UT N011C£.. PllOECT: DRAWINGS HEr 3 1F2 APl'llMll BY': M PAULSEN IO-SEP-15 lm!ECmN

1/0 CABINET-I POWER CABINET-1 BATIER'!' CABINETS-1

AIR OUT1.ET HOUS-RE"AR. IT IS filOWED TO 11.0CK

lHESE HOUS. NO RE"AR ClfNlANCE REWIRED

NOTES:

J9.5J [1004]

1. INSTALLATION SHALL COMPLY WITH ALL APPLICABLE NATIONAL, STATE AND LOCAL CODES.

2. REFER TO PRODUCT DOCUMENTATION FOR ADDmONAL DETAILS PRIOR TO INSTALlATION AND SITE PREPARATION WORK.

3. ALL DIMENSIONS ARE IN INCHES [MIWMETERS].

• •

• •

1HS mAWNl NID SPEafrATIONS HEREIN /1£. n£ PROPER1Y OF sctf4EllER El..ECIRIC NID SHAU. NOT BE CCftD, REPRODUCm OR USED IN WHCl.E OR N PART, ~ lHE BASIS RR n£ llANUF'ICl'IH: OR SALE OF llEMS Wl1HOUT IRll1tN PERMISSION FR<* SQINEIDER

El..EClRIC. lHIS DRAWING IS BASED ll'ON l.A1EST AVAll.lilll.E INRRM'IDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE.

•

•

1/0 CABINET-2

DD [][] [][]

POWER CABINET-2

[!] [!]

c:::::::J c:::::l c::::::> c:::::l c:::::::J c:::::l

c:::::::J c:::::l c::::::> c:::::l c:::::::J c:::::l

c:::::::J c:::::l c::::::> c:::::l c:::::::J c:::::l

c:::::::J c:::::l

•

BATI'ERY CABINETS-2

• • •

• •

llRE: Galaxy w Diil MO: GVM 160KG65MODB 1 OR2 REV. O S h •d Input: 4lKJll I( 3PH DUrMSINGLI MAINS C~'1el er 2YllJ.llN:iutis4B~~~=CABINEIS DRMNB\': NAGENDRA 10-SEP-15 HIRD

v Electric 1----SOL_ un_o_N-_RfAR_ 'll_,EW.-----+-D«HER: ____ c N«mJr _ __,__00 ___ 10_- _sE_P-_1_s _~ NGLE PRWECTIOO PRnECl': DRAWINGS Sl£El' 4 11'21 N'PllMD Ill': M PAULSEN 10-SEP-15

NARROW B/l.TT CAB-28 ...------"----

WIDE B/l.TT CAB-2A

PERFORAlED AREA (TYP)

e• •e

PERFORAlED AREA (TYP)

0

0

FRONT

POWER CABINET-2

-=· = . M "

PERFORAlED AREA {TYP)

0

22.80 [579]

• • 0

.&, DIMENSIONAL DETAILS

TOP BA'llNG BRACKET(TYP.) 1/0 CABINET-2 NARROW BATT CAB-18

TOP VIEW

WIDE BATT CAB-1A

PERFORATED AREA {TYP)

25.55 i----2-2.-JO [649] __ _

[566]

e' •e

PERFORATED AREA {TYP)

0

POWER CABINET-1

-==== . M "

NETWORK CABLE ENTRY - TOP (NP.)

PERFORATED AREA {TYP)

22.80 [579]

& 1 J.54 [J#] I 14.41 [J66] (NP.) CABLE ENTRY ARfA FOR ll11UTY/MAINS INPllT CABL£S, BYPASS INPllT CABLES, OUTPUT CABLES AND ClPTKJ'W. BATI'ERY CABLES. (DRIU/PUNCH HOlLS FOR CONDUITS)

FlEl.D WIRING ClllE EN1RY - TOP (NP.)

1.02 [26]

2.90 [7+]

l.EVEUNG FOOT (4 Pl.f.CES) (NP.)

& PBUS ClllE ENTRY - OOTTOM (n'P.)

& 1J.54 [J44] • 14.41 [J66] (NP.) CABLE ENTRY ARfA FOR UTILITY /MAINS INPUT CABLES. BYPASS INPllT CA8LES, DllTPllT CABLES AND OPTIONAL BATTIRY CAllLES . (DRILl/PUNCH HOLES FOR CONDUITS)

BOTIOM VIEW BA'llNG BR/.Cl<ET-RfAR (NP.)

NOTES: 1. INSTALLATION SHALL COMPLY WITH ALL APPLICABLE NATIONAL,

STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUMENTATION FOR ADDITIONAL DETAILS

PRIOR TO INSTALLATION AND SITE PREPARATION WORK. 3. ALL DIMENSIONS ARE IN INCHES [MILLIMETERS].

6. 4. DRILL/PUNCH HOLES IN PLATE. REMOVE PLATE FROM CABINET BEFORE DRILLING/PUNCHING. INPUT POWER/COMMUNICATION CABLE ENTRY IS FROM TOP OR BOTTOM OF THE UNIT.

lHIS mAWNl NID SPEaFICA~ HEREIN N£ 1l£ PROPERlY OF SCHNEllER El..ECIRIC NID SHAU. NOT BE COPED. REPRODUCED OR

USED IN WHCl£ OR IN PART, Mi lHE BASIS FOR 1l£ llANUF'AC'l\H: OR SALE OF llEMS WITHOUT \Rl1tN PERMISSION FROM SCHNEllER

El..ECIRIC. llilS DRAWING IS BASED IJ'ON LATEST AVAllJilll.£ lhRRIATION AN> IS SlaJECr TO awa Wl1HOUT NOTICE.

llll£: Galaxy VM DIG NO: GVM 160KG65MQDB 1 OR2 IU. 1 S h •d Input: 480\I 11:, JPH ~SINGLI MAINS

CA'1el er 21iw.nN/i~PS48~~~~~c>.e~rn DRMlll B'f: NAGENDRA M--JAN-18 HIRD v- Electric 1---so_wn_oo_-_m_P_AN_o_s_01T....,o ..... M_'ll_EWS_--+_ENCHER: ____ c .wJEm/1' _ __,__oo-+-_a4_-_JAN_-_1_e _ _ NGLE

FRWE£1100 PllllECT: DRAWi NGS Sl£El' 5 11'2 f.fPllMD Bl': M PAULSEN 04-JAN-18

78.46 [1993] 69.79

[1773] 64.37 [1635] 53.11

REAR [1349] 41.85 ANCHORING [1063] 33.29

BRACKET [845] {'7 24.23 [615] 15.57 - [395J-----s:52 1.22

1 [165] ~ 1 [31]

TYP.

I 041. 0 . A e .I -- =te • ---0 oil al -- II ~~r 0 . -- -+ · ~ --

I I I I I I I I & I I I I I I

I I I I I

I BAYING RACKET

I I I I I (UPS&l-0) 34.09 I I I I

I I [866]

BATTERY BATTERY I

CABINET-28 I BATTERY CA81NET-2A POWER CABINET-2 1/0 CABINET-2 I CABINET-18 I BATTERY CA81NET-1A I POWER CABINET-1 I 1/0 CABINET-1 I TYP.

32.09 I I I I I [815] I I I I

I I

I I I I I

I •0.71 TYP.

I [•18] I I I I

I (20 PLACES)

I I I I

I I I I I I

I I I I-Q I -a- ·I G-r ....... , I I-< ~ I .... I ......

t L 14.49 _j .99

.&_ DIMENSIONAL DETAILS &j I-- [25]

FRONT FRONT [368]-

ANCHORING 16.70 BRACKET 27.43

- [424]

(4 PLACES) 38.15 [697]

40.35 [969]

48.62 [1025]

57.47 [1235]

65.74 [1460]

67 .83 [ l67D]

80.11 [1723]

[2035] 81.35 [2066]

TOP VIEW MOUNTING HOLE LOCATIONS FOR ANCHORING BRACKETS

NOTES: 1. INSTALLATION SHALL COMPLY WITH ALL APPLICABLE NATIONAL, STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUMENTATION FOR AODmONAL DETAILS PRIOR TO INSTALLATION AND SITE PREPARATION WORK. 3. ALL DIMENSIONS ARE IN INCHES [MILLIMETERS] .

.ll.4. FIXATION OF ANCHORING BRACKETS IN FRONT IS OPTIONAL IN NON-SEISMIC LOCATIONS. FOR SEISMIC COMPLIANCE USE CODE COMPLLANT FASTENERS Tl SECURE UNIT TO lHE FLOOR .

.ll.5. USE lHE BAYING BRACKET lHAT WAS ATTACHED TO THE REAR PALLET OF 1/0 CABINET FOR ANCHORING THE UNIT. REAR BAYING BRACKET MUST BE BOLlED TO THE FLOOR.

1HS mAWNl NID SPEafrATIONS HEREIN /1£. n£ PROPER1Y OF llRE: Galaxy VM DIG MO: GVM 160KG65MODB 1 OR2 RlV.o 6. IN AREAS WHERE SEISMIC PROTECTION IS REQUIRED, FOLLOW THE INSTRUCTIONS IN GVM65KANCHORING-SA DRAWING. sctf4EllER ELECTRIC NID SHAU. NOT BE CCftD, REPRODUCm OR

Sc~'1eider Input: 4lKJll I( 3PH DUrMSINGLI MAINS

7. FOR INSTALLATION ON RAISED FLOOR, FOLLOW THE INSTRUCTIONS IN USED IN WHCl.E OR N PART, ~ lHE BASIS RR n£ llNIUFICl'IH: 2 11nnN/iutis 48~ ~~ = CABINETS DRMN Bl': NAGENDRA 10-SEP-15 THIRD

GVM65KANCORING-RF DRAWING. OR SALE OF llEMS WlllWf IRll1tN PERMISSION FR<* SQINEIDER Electric SOLUTION-ANCHORING DETAILS D«HER: C .wll&N/Y DU 10-SEP-15 ANGLE ELECTRIC. lHIS DRAWING IS BASED ll'ON l.A1EST AVAll.lilll..E 8. FLOOR ANCHORING BOLTS ARE NOT SUPPLIED. INRRM"IDI ~D IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE. PRnECf: DRAWI NGS lstm 6 11'21 N'PllMD Ill': M PAULSEN 10-SEIP-15 PRWECTIOO

POWER CABINET MAIN CONTROUfR

(REFER TO SHEET-13)

VlEW-B (REFER TO SHEET-8)

SMART Sl.OlS&

• • .

.

.

' • •

';;;;:/

NOTES:

.•I I . I I I ••• ,__J D LL • D D

. . .

. . .

. . / I .

I • 0,. ~/

I .. ,. . I • .0

\ . .

D .

D

D •

LEFT SIDE VIEW (INTERNAL)

. \

.

. .

. . .

D ~ .-:' •• •· .

'=

~

~ DC+

~ DC-

-

\__

FRONT

SIDE SKIN REMOVED

- BATTERY GROUND

RX TERMINATION IS PROVIDED WrTH THE

PROD (REFER TO SHEET-9

FOR DETAILS)

1. INSTAUATION SfW.L COMPLY WITH ALL APPLICABLE NATIONAL, STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUMENTATION FOR ADDITIONAL DETAILS PRIOR TO INSTALLATION

AND SITE PREPARATION WORK. 3. ALL DIMENSIONS ARE IN INCHES [MILLIMETERS] .

FRONT VIEW (INTERNAL)

.ti.4. BUSBAR LINKS ARE APPLICABLE FOR SINGLE MAINS SYSTEM ONLY. (REMOVE FOR DUAL MAINS) 5. SOME STRUCTURAL DETAILS HAVE BEEN OMITTED FOR THE PURPOSE OF CLARllY •

.ti.6. FRONT SERVlCE ACCESS ONLY.

1/0 CABINET

VlEW-A (REFER TO SHEET-8) 1/0 CABINET

POWER CABINET TO 1/0 CABINET INTERFAC (TYP)

E · ,!I· 0 I ·l!.· ~

{BUSBAR TOP COVER SHOWN FOR CLARITY)

NOT

1.J1i----+---1:-t--PCB-1 REFER TO SHEET-13

62.81 30.06 [1595]

6.71 5 [1 440]

54.94 [1395]

43.60 [1107]

0 0 . • 1.· I

D Oii Oii I llD Oii

II & r~

<.......J = " •

INPUT L2-...... ~ ~ : :~

• L3---.... .........,...., = G~

n.

& J.J/J

l--BUSBAR LINKS____...

G__., roi .......__ r-...i--.. ~

/ ,/I

&{'-, .... . • • L3_/ / ::::::::> :~:[ BYPASS L2 ___//

L1 _./ ::::::::> ........... .---{

&r~· ........J ~

N----..._ '- ::::::::> c:::::::J

OUTPUT L1 ----..._ '-. §....,_ d L3---.._ ~ I

I i . ,,

[763] 2.~ G--...... ~ l 41.83 E--...... cu. 1"-

14.23 [361]

37.62 [955]

[1062] ~

24.59 [624-]

20.18 [512]

18.05 [458] ~

., . '--' '-'L = = . ,-----; ,------,

um:m~ /

. • •

•

. . •

•

. . •

• • ..

POWER CABINET

~

['] ['] '

r::::::=J c==:;;i r::::::=J• c==:;;i r::::::=J c==:;;i

r::::::=J c==:;;i r::::::=J• c==:;;i c::::=i c=:::::::J

r::::::=J c==:;;i r::::::=J• c==:;;i r::::::=J c==:;;i

r::::::=J c==:;;i •

r::::::=J• c==:;;i r::::::=J c==:;;i

r::::::=J c==:;;i r::::::=J• c==:;;i r::::::=J c=:::::::J

•

•

' ~

! :¥a • . 0J]..: 0 •• ·~@ ••

Doi .. C> C> . . I a PCB-3 REFER TO SHEET-14

CONTACTOR TO_/ ill REAR VIEW (INTERNAL) TIE NEUTRAL TO LOCAL GROUND

NO REAR ACCESS REQUIRED FOR SERVlCE. .ti.7. NETWORK MANAGEMENT CARD IS OPTIONAL AND TO BE ORDERED

SEPARATELY. THE RECOMMENDED NETWORK MANAGEMENT CARDS ARE: AP9630/AP9631/AP9635.

1HS mAWNl NID SPEarrATIONS HEREIN /1£. n£ PROPER1Y OF sctf4EIDER El..ECIRIC NID SHAU. NOT BE CCftD, REPRODUCED OR

USED IN WHCl.E OR N PART, ~ lHE BASIS RR n£ llANUFICl'IH:

llRE: Galaxy w Diil MO: GVM 160KG65MODB 1 OR2 REV. O S h •d Input: 480\I AC 3PH DUrMSINGLE MAINS C~'1el er 2YllJ.llN:iutis4B~~~=CABINEIS DRMNB\': NAGENDRA 10-SEP-15 HIRD

.ti.B. FOR BUSBAR DETAILS REFER TO SHEET-9.

OR SALE OF llEMS Wl1HOUT IRll1tN PERMISSION FR<* SQINEIDER El..EClRIC. lHIS DRAWING IS BASED ll'ON LATEST AVAll.lilll.E INRRMlDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE.

v Electric 1---u_PS_(s_1NGlf) __ 1N_TER_N_AL....,...,,....EWS_ -_1 ___ D«HER: ____ c N«mJr _ __,__00 ___ 10_- _sE_P-_1_s _ . NGLE PRWECTIOO PRnECf: DRAWINGS stm 7 11'21 N'PllMD Ill': M PAULSEN 10-SEP-15

It.PUT

FIX THE CABINETS TOGETHER HERE

llB

• .. USING MB SCREW.

FIX THE CABINETS TOGETHER HERE

. • USING MB SCREW.

Ll D G

D D D ·o I

.. FRONT-

0

D D G

.. . . D

.. FIX THE CABINETS

FIX THE CABINETS 54.74 TOGETHER HERE

TOGETHER HERE [1390] USING t.18 SCREW.

USING MB SCREW.

D D SSS

48.05

BD [1220]

G

20.10 [51 OJ 0 !EB

D D 24.53 17.95 IUB

[623] [456] . ! • INTERCONNECTING

GROUND BUSBAR TO POWER CABINET

0 VIEW-A VIEW-B ~

POWER CABINET INPUT [OUTPUT FRAME

NOTES: 1. INSTAl..1.ATION SHAl..l COMPLY WITH All APPLICABLE NATIONAL, STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUMENTATION FOR ADDITIONAL DETAILS PRIOR TO INSTALLATION AND

SITE PREPARATION WORK. 3. All DIMENSIONS ARE IN INCHES [MILLIMETERS]. 4. SOME STRUCTURAL DETAILS HAVE BEEN OMITTED FOR THE

PURPOSE OF Cl.f\RITY. Ll.5. USED FOR SYSTEMS WITH REMOTE BATTERIES OR

BATTERY BREAKER ENCLOSURE ONLY.

1HS mAWNl NID SPEafrATIONS HEREIN /1£. n£ PROPER1Y OF sctf4EllER El..ECIRIC NID SHAU. NOT BE CCftD, REPRODUCm OR

USED IN WHCl.E OR N PART, ~ lHE BASIS RR n£ llNIUFICl'IH: OR SALE OF llEMS Wl1HOUT IRllTEN PERMISSION FR<* SQINEIDER

El..EClRIC. lHIS DRAWING IS BASED ll'ON l.A1EST AVAll.lilll.E INRRM'IDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE.

LOAD

FLOW DIAGRAM

llRE: Galaxy w Diil MO: GVM 160KG65MODB 1 OR2 REV. O S h •d Input: 4lKJll I( 3PH DUrMSINGLI MAINS C~'1el er 2YllJ.llN:iutis4B~~~=CABINEIS DRMNB\': NAGENDRA 10-SEP-15 HIRD

v Electric 1---u_Ps_(s_1N_cLI_)_1NTE_ RNAL__,vi ..... EWS_ -_2 ___ D«HER: ____ c _.wmNJr_-'--oo-+--10_- _sE_P-....;1..;..s __,. NGLE PRnECl': DRAWINGS Sl£El' 8 11'21 N'PllMD Ill': M PAULSEN 10-SEP-15 PRWECTIOO

o~: ~ . . . :o . . . . I

I I

I /

/

-------

I t

I

0 0

.riQJIS;_

/ ---- ., -- -------.....:..... /., ------ ------INTERCONNECTION BUSBAR DETAILS

(ENLARGED VIEW)

~-:------- __ / ~

INTERNAL ISOMETRIC VlEW SHOWING BUSBAR CONNECTIONS

(BUSBAR TOP COVER NOT SHOWN FOR CLABITYl

~-----, ., ... ,,

1. INSTALlATION SHALL COMPLY WITH ALL APPLICABLE NATIONAL.STATE AND LOCAL CODES. /

I I

J

2. REFER TO PRODUCT DOCUMENTATION FOR ADDITIONAL DETAILS PRIOR TO INSTALLATION AND SITE PREPARATION WORK.

3. ALL DIMENSIONS ARE IN INCHES [MILLIMETERS]. 4. SOME STRUCTURAL DETAILS HAVE BEEN OMITIED FOR THE PURPOSE OF CLARllY.

b.5. ALL THE INTERFACE PARTS ARE SUPPLIED WITH THE UNIT.

INTERCONNECTION GROUND BUSBAR DETAILS (ENLARGED VIEW)

66. SCHNEIDER ELECTRIC RECOMMENDS: THAT THE POWER CABINET IS TO BE INSTALLED AS lATE AS POSSIBLE TO AVOID

BUSBAR DETAILS

UPS INPUT CONNECTION BUSBAR/ GROUND BUSBAR- 5 [0.20] Thick

.43 .79 [1111] [20]

(2 PLACES)

.43 [1111]

(4 PLACES)

.43 [1111]

(2 PLACES)

L 1 /L2/L3 BUSBAR NEUTRAL BUSBAR

BYPASS INPUT /NEUTRAL CONNECTION BUSBAR- 5 [0.20] Thick

.43 [1111]

(2 PLACES)

1.38 t---<+---- [35]

BUS BAR

.43 [1111]

(2 PLACES)

BUS BAR

OUTPUT/LOAD CONNECTION BUSBAR- 5 [0.20] Thick

1.57 .79

~] [20]

.71 .43 [18] [•11]

(4- PLACES)

1.97 D 0

[50] 0 0

DC CONNECTION BUSBAR- 5 [0.20] Thick

CONSTRUCTION DEBRIS AND DUST ACCUMUlATING INSIDE IT. .--lHS-mAYl'Nl--Nl-D_SPEa_ArA_JIONS __ HER-EIN-11£._TI£_PROPER1Y ___ OF---.-------"""T"::llRE:=::-· ---G-ala_X"f_VM ____ ,...,,Dlll~MO,,....: _G_V_M_16_0_K_G_6_5_M_O_DB_1_0_R_2-=19,,.,._-o---1 THAT THE ROOM IS TO BE PROPERLY CLEANED AFTER THE sctf4EllER El..ECIRIC NID SHAU. NOT BE C(ftl), REPRODUCm OR s h .d Input: 4lKJll "' 3PH DUALlSINGLI MAINS COMPLETION OF CONSTRUCTION WORK AND BEFORE THE USED IN WHCl.E ORN PART,~ lHE BASIS RR n£ llANUFICllH: C

0nel er 2 ~'lEOut1 tplu~~48~-1£...,J.ffi, l~ "'"INEJS DRMN Bl': NAGENDRA 10-SEP-15 HIRD

POWER CABINET IS INSTALLED. OR SALE OF nEMS Wl1HOUT IRllTEN PERMISSION FR<* SQINEIDER El t • """"' .... , """ """'"'" ..,.,.,., """ VACUUM CLEANING OF THE 1/0 CABINET AFTER CABLE INSTALLATION. El..EClRIC. lHIS DRAWING IS BASED ll'ON l.A1EST AVAll.lilll.E ec nc UPS(SINGLE) INTERCONNECTION BUSBAR DETAILS DRIER: c .wll&N/Y DU 10-SEP-15 NGLE

INRRM'IDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE. PRnECf: DRAWI NGS stm 9 11'21 N'P11MD Ill': M PAULSEN 10-SEP-15 Pl!WEC1100

• .•I I • I

• D . D

I

I

.

. D

• D • . •

\;:;;:;/

MAIN CONTROllER (REFER TO SHEET-13)

I •• • LL • D

• 0

. .

. / . 0.,.. ~ . / 0 D .-i !;it

I • .0

\ . .

D \ . .

.

0

D ~ ~ ~ •• • ~-

F

,,,-- DC+

~ DC-

-FRONT

\_

,,.....--

SIDE SKIN REMOVED

BATIERY GROUND

POWER CABINET

VIEW-8 (REFER TO SHEET-11)

SMART SLOl"S ffi

1/0 CABINET

i--- ...,.1EW-A (REFER TO SHEET-11)

POWER CABINET TO l/D CABINET INTERFACE (lYP) (BUSBAR TOP COVER NOT SHOWN FOR CLARITY)

MIB KIRKKEY

Q.ll·---~..+-PCB-1

REFER TO SHEET-13

56.71 [1440]

& l N BYPASS ~ L1

54.94 [1395]

&fl2 OUTPUTl ~

62.81 [1595]

37.62 [955]

43.60 [1107]

41.83 [1062]

24.59 [624]

G

E

LEFT SIDE VIEW (INTERNAL)

RX TERMINATION IS PROVIDED WITH THE

PRODU (REFER TO SHEET-12

FOR DETAILS) FRONT VIEW (INTERNAL)

PCB-3 REFER TO SHEET-14

CONTACTOR TO TlE NEUTRAL TO

LOCAL GROUND

NOTES: 1. INSTAUATION SHALL COMPLY WITH ALL APPLICABLE NATIONAL. STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUMENTATION FOR ADDITIONAL DETAILS PRIOR TO INSTAUATION

AND SITE PREPARATION WORK. 3. ALL DIMENSIONS ARE IN INCHES [MILLIMETERS].

ll.4. BUSBAR LINKS ARE APPLICABLE FOR SINGLE MAINS SYSfEM ONLY. (REMOVE FOR DUAL MAINS) 5. SOME STRUCTURAL DETAILS HAVE BEEN OMITTED FOR THE PURPOSE OF CLARITY.

1/0 CABINET POWER CABINET

[i] [i]

i::::=J I ;;;i

i::::=J•I ;;;i

i::::=J I ;;;i

i::::=J I ;;;i

i::::=J•I ;;;i

c::=i I ;;;i

i::::=J I ;;;i

i::::=J• I ;;;i

• i::::=J I ;;;i

i::::=J I ;;;i

• i::::=J•1 ;;;i

i::::=J I ;;;i

i::::=J I ;;;i i::::=J•I ;;;i

i::::=J I ;;;i

•

•

fl.6. FRONT SERVICE ACCESS ONLY. NO REAR ACCESS REQUIRED FOR SER\11CE.

fl.7. NETWORK MANAGEMENT CARD IS OPTIONAL AND TO BE ORDERED SEPARATELY. THE RECOMMENDED NETWORK MANAGEMENT CARDS ARE: AP9630/AP9631/AP9635.

1HS mAWNl NID SPEafrATIONS HEREIN /1£. n£ PROPER1Y OF sctf4EIDER El..ECIRIC NID SHAU. NOT BE CCftD, REPRODUCm OR

USED IN WHCl.E OR N PART, AS lHE BASIS RR n£ llANUFACTIH:

llRE: Galaxy w Diil MO: GVM 160KG65MODB 1 OR2 REV. O S h •d Input: 4lKJll I( 3PH DUrMSINGLE MAINS

fl.8. FOR BUSBAR DETAILS REFER TO SHEET-12.

OR SALE OF llEMS Wl1HOUT IRll1tN PERMISSION FR<* SQINEIDER El..EClRIC. lHIS DRAWING IS BASED ll'ON l.A1EST AVAll.lilll.E INRRM"IDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE.

C~'1el er 2YllJ.llN:iutis4B~~~=CABINEIS DRMNB\': NAGENDRA 10-SEP-15 HIRD v Electric 1---u_PS(_R_rn_uN_DANTJ __ 1NTER_ NAL....,....'Yl_EWS-_ 1 __ D«HER: ____ c N«mJr _ __,__00 ___ 10_- _sE_P-_1_s _ _ NGLE

PRnECf: DRAWINGS stm 10(1'21 N'PllMD Ill': M PAULSEN 10-SEP-15 PRWECTIOO

FIX lHE CABINETS TOGETHER HERE

USING f.IB SCREW.

FRONT -

FIX lHE CABINETS TOGETHER HERE

USING f.IB SCREW.

•. .

D D D D ·o

D D· D

D D.

BO D D·~

54.74 [1390]

G

G

48.05 .,....-------1--f't-------+o

[1220]

20.10 [51 O]

22.66 17.95 [575] [ 456] •

VIEW-B

FIX lHE CABINETS TOGElHER HERE USING MB SCREW.

FIX lHE CABINETS TOGETHER HERE USING MB SCREW.

G

0

0 ....

I

I

I-:--

VIEW-A POWER CABINET INPUT /OUTPUT FRAME ~-

NOTES: 1. INSTAl..1.ATION SHAl..l COMPLY WITH All APPLICABLE NATIONAL, STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUMENTATION FOR ADDITIONAL DETAILS PRIOR TO INSTALLATION AND

SITE PREPARATION WORK. 3. All DIMENSIONS ARE IN INCHES [MILLIMETERS]. 4. SOME STRUCTURAL DETAILS HAVE BEEN OMITTED FOR THE

PURPOSE OF Cl.f\RITY. Ll. 5. APPLICABLE FOR SYSTEMS WITH REMOTE BATTERIES OR

BATTERY BREAKER ENCLOSURE ONLY.

1HS mAWNl NID SPEafrATIONS HEREIN /1£. n£ PROPER1Y OF sctf4EllER El..ECIRIC NID SHAU. NOT BE CCftD, REPRODUCm OR USED IN WHCl.E OR N PART, ~ lHE BASIS RR n£ llNIUFACTIH: OR SALE OF llEMS Wl1HOUT IRll1tN PERMISSION FR<* SQINEIDER

El..EClRIC. lHIS DRAWING IS BASED ll'ON l.A1EST AVAll.lilll.E INRRM'IDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE.

FLOW DIAGRAM

llRE: Galaxy w Diil MO: GVM 160KG65MODB 1 OR2 REV. O S h •d Input: 4lKJll I( 3PH DUrMSINGLI MAINS C~'1el er 2YllJ.llN:iutis4B~~~=CABINEIS DRMNB\': NAGENDRA 10-SEP-15 HIRD

v Electric 1---u_PS_(R_rn_uN_DANTl __ 1NTER_ NAL....,...."1_EWS_-_2 __ D«HER: ____ c _.wmNJr_-'--oo-+-_10_- _sE_P-....;1..;.,s __,. NGLE PRnECl': DRAWINGS stm 1111'21 N'PllMDll\': M PAULSEN 10-SEP-15 PRWECTIOO

I

---

I I

I /

/

------

, /

/ I

I

----------.........:._ ____ _ /

0 INTERCONNECTION BUSBAR DETAILS

(ENLARGED VIEW)

- ---- ;"" ---- ------....__ --

.riQJIS;_

INTERNAL ISOMETRIC VIEW SHOWING BUSBAR CONNECTIONS

(BUSBAR TOP COVER NOT SHOWN FOR CLARllY)

1. INSTALLATION SHALL COMPLY WITH ALL APPLICABLE NATIONAL.STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUMENTATION FOR ADDITIONAL DETAILS PRIOR TO INSTALLATION AND

SITE PREPARATION WORK. 3. ALL DIMENSIONS ARE IN INCHES [MILLIMETERS]. 4. SOME STRUCTURAL DETAILS HAVE BEEN OMITIED FOR THE PURPOSE OF CLARllY.

b.5. ALL THE INTERFACE PARTS ARE SUPPLIED WITH THE UNIT. 66. SCHNEIDER ELECTRIC RECOMMENDS:

THAT THE POWER CABINET IS TO BE INSTALLED AS LATE AS POSSIBLE TO AVOID

....__ ....__

I \

\ / /

/

INTERCONNECTION GROUND BUSBAR DETAILS (ENLARGED VIEW)

BUSBAR DETAILS

UPS INPUT CONNECTION BUSBAR/ GROUND BUSBAR- 5 [0.20] Thick

.43 .79 [1111] [20]

(2 PLACES)

.43 [1111]

(4 PLACES)

.43 [1111]

(2 PLACES)

L 1 /L2/L3 BUSBAR NEUTRAL BUSBAR

BYPASS INPUT /NEUTRAL CONNECTION BUSBAR- 5 [0.20] Thick

.43 [1111]

(2 PLACES)

1.38 t--<+-- [35]

BUS BAR

.43 [1111]

(2 PLACES)

BUS BAR

OUTPUT/LOAD CONNECTION BUSBAR- 5 [0.20] Thick

1.57 .79

~] [20]

.71 .43 [18] [•11]

(4 PLACES)

1.97 D D

[50] 0 0

DC CONNECTION BUSBAR- 5 [0.20] Thick

CONSffiUCTION DEBRIS AND DUST ACCUMULATING INSIDE IT. .--lHS-mAYl'Nl--Nl-D_SPEa_ArA_JIONS __ HER-EIN-11£._TI£_PROPER1Y ___ OF---.-------"""T"::llRE:=::-· ---G-ala_X'f_VM ____ ,...,,Dlll~MO""": _G_V_M_16_0_K_G_6_5_M_O_DB_1_0_R_2-=19,,.,._-o--t THAT THE ROOM IS TO BE PROPERLY CLEANED AFTER THE sctf4EllER El..ECIRIC NID SHAU. NOT BE C(ftl), REPRODUCm OR s h .d Input: 4lKJll "' 3PH DUALlSINGLI MAINS COMPLETION OF CONSTRUCTION WORK AND BEFORE THE USED IN WHCl.E ORN PART,~ lHE BASIS RR n£ llANUFICllH: C

0nel er 2 ~'lEOut1 tplu~~48~.1£....J.ffi. l~ "'"INEJS DRMN Bl': NAGENDRA 10-SEP-15 HIRD

POWER CABINET IS INSTALLED. OR SALE OF nEMS Wl1HOUT IRllTEN PERMISSION FR<* SQINEIDER El t • """"' ... , """ """'"'" ..,.,.,., """ VACUUM CLEANING OF THE 1/0 CABINET AFTER CABLE INSTALLATION. El..EClRIC. lHIS DRAWING IS BASED ll'ON l.A1EST AVAll.lilll.E ec nc UPS(REDUNIWIT) l~NECTION BUSIWl DETAILS D«HER: c .wll&N/Y DU 10-SEP-15 NGLE

INRRM'IDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE. PRnECf: DRAWI NGS stm 1211'21 N'P11MD Ill': M PAULSEN 10-SEP-15 Pl!WEC1100

EPO CONTROL DIAGRAM ~

NC NO Al 24 VDC/NC 24 VDC/NO ~

A:~ '~ ' A:~ ~ A ' A '

I;;

.;8 + z+Y u ~ ' '[fil !I;; ~I;; B ' B ' B ' s;g

1 I 1 :z :;!; Q~ =~ c :IBP '[fil c :IBP ' '[fil

I . ~· c:g c ' c:g ~~ ~~

~'.3 ')''.3 :::> 815 ~8

&::& ~o ;!l; -, "'

~~ ~~ ::::> ~')' ~ ~:b ;!l; I.LI

~8 ~~ ;!l; ~ ~ ~ Cl + :z "' <..> I.LI I.LI I.LI '-" 5 ........ c'

CJ (/) (/) (/) al'~ :zo

~ ~ ~ ~ ~ ~ Cl ¥.,. 51-I.LI :z: "'"' "' "' "' N en N '-" "'o coo

• i1ii 4V SELY SlJIPLY OOT 0 24V SUPPLY A OUT

~~ ~ 2~1~1 2::~~1 + + GND ~ ....

=i ••• ;:

• e MAIN CONTROLLER

@ MAIN CONTROLLER [ MIMIC @ MODEL:

I n 11.:::'1 ... 1 SERIAL:

:0]®@@®11 I ~u I I I

t:i

~ I;;

~t:i ~ uz ~I;; Vi iii ~<3 Q~ u· ;!l;~ ~-!~ ;!;~ O::J 7'.3 ID Cl no 8:::> -, ::Ii ~a

~~ -, §: ::;2~ - .... !l, I -..,

~"' ~I ,_8 I!' :3 z"" !z:;;: :::>-, :::>-, Io VI I- ~ 12 UI>: 00 815

MAINTENANCE BYPASS l[O PCB-1 DETAILS

"'"' a.. a.. in; ,_ ,_ z z ::::> ::::> II VI VI

uu cc

0

J [ II®@

CONNECT THE EPO ACCORDING TO ONE OF THE OPTIONS SHOWN IN 5

c.. THE EPO CONTROL DIAGRM1 5 0

CD '-" "f '-' u:: I I ~ 0 0 :z

c.. c.. 0 I.LI ..... L.J u ,....-...., ,....-...., ,....-...., ,....-....,

••• • •••••

S/N._I -----' REVL::]

]! 0

D@

N ...., 5 5 c.. c.. 5 5 0 0

'-" '-" u:: u:: :z :z 0 u

0 u ,....-...., ,....-....,

I DISPLAY I 1~1"""1 10 ~ 100 PBUS1 PBUS2 ABUS MODBUS

NOTES: 1. INSTALLATION SHALL COtJPLY WITH ALL APPLICABLE NATIONAL,

STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUtJENTATION FOR ADDITIONAL DETAILS

PRIOR TO INSTALLATION AND SITE PREPARATION WORK.

NETWORK

1HS mAWNl NID SPEafrATIONS HEREIN /1£. 11£ PROPER1Y OF sctf4EIDER El..ECIRIC NID SHAU. NOT BE CCftD, REPRODUCm OR

USED IN WHCl.E OR N PART, ~ lHE BASIS RR 11£ llANUFICl'IH: OR SALE OF llEMS Wl1HOUT IRllTEN PERMISSION FR<* SQINEIDER

El..EClRIC. lHIS DRAWING IS BASED ll'ON l.A1EST AVAll.lilll.E INRRMlDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE.

llRE: Galaxy w Diil MO: GVM 160KG65MODB 1 OR2 REV. O S h •d Input: 4lKJll I( 3PH DUrMSINGLE MAINS C~'1el er 21m.nN:iutis4B~~~=CABINEIS DRMNB\': NAGENDRA 10-SEP-15

v Electric UPS(~tm/IEJ.HllM1J 1/0 Pa1-1 & llllN coN1R0UIR D«HER: c N«mJr oo 10-sEP-1s PRnECf: DRAWINGS stm 1311'21 N'PllMD Ill': M PAULSEN 10-SEP-15

NGLE PRWECTION N.A

t;:; t;:; MAINTENANCE BYPASS 1/0 PCB-2 DETAILS 5 z z ~ ~ ~ z: 5 ::c 0

~ ~ 5 ~ !l; g a.. ;ic ;!;; z 0 5 ~

SO! SO! "' I';; 0 z a.. !"l "' "' ""

z Cl a: 0 5

~ ~ a: 0

~ ::c

~ z:

~ ~ I- '-' 0 "" I- I- :::> ~ a: '-' :::> :::> a.. z CJ z a.. a.. 5 "" I ~x ~x I- 5 5 5 5 5 UJ 0

~ 5 5 0 ~ :::> a.. a: z: 0 :-.! a:

';'~ ,~ "- "- "- "- "- "- 2"i «!5 :i:: 0 0 0 z: ::c ::::> ;!;; ~ ~ ~ ~ ~ '-' ~ '-' I- z: "- I';; 15 ~ ~ a:

~ 8 "'"' "'"' ~ ~ 8 0"" ow ~ ~ ~ ~ ~ ~ a:

~~ ffi ~ ~ a:

"""" """" UJ (.)

~~ ~~ ~ ~ ~ ~ ~ ~ :IE :-.! ~ :::> :-.! :-.! z: "' a: 8 ~

:::> :::> ~ Cl :ZQ z o~ ~~ :::> :::> :::> :::> :::> :::> ~ 8~ z: t;; "' "' UJ z :::> 15 I- "' "' "' '-" '-" "' "' a: c:;: c:;: :z &1

a: a:~ a: :z

~1 ~1 ;!;; c:;: c:;: c:;: c:;: c:;: c:;: "' :::>

8 ~ z z 0 8 ~z: "" 0 LAMP OUTPUTS :z z z z: z: z:

~ b ~z ~ 0 0 (.) ~ "' ID

~ 0 0 0 0 0 0 ~~

:::> (.) (.) I UJO I I (.) (.) (.) (.) (.) (.) z I I I I I 0 I I I a:: "" "' ..!.. I I 4 I I I I ::c

~ .... "" "' ... "' <D::C ID al ID

"" ..,

"' ... .... "' .,,u

§~ g ID !!l u; ~ ;!;;~ 5 5 5 5 5 5 5 5 "' VI "' ;!;; ~ ~ ;!;; ;!;; ~ ~ z ;!;; ~ 0 0 0 0 0 0 0 0 ::c ::c ::c ::c i :5 i :5 "" ,..-...... ,..-...... ,..-...... ,..-...... ,..-...... ,..-...... ,..-...... ,..=.-._ ,..-...... ,..-...... ,..-...... ,....-...., ,....-...., ,....-...., ,....-...., ,....--..... ,....-...., ,....-...., ,....--..... ,....-...., ,........__ ,........__ ,........__ ,........__

• e

;!; u c

~

~

•• • • • • ••

• • • • • • • • • •

P l40-Jll40.l-Z AE'IOI e lll1intm1MC11 lypcm l/D 1 .. 111 ]!

~012 APC br Sdi111dr Ellctric

MAINTENANCE BYPASS 1/0 PCB-3 DETAILS

• • ••

• • • • •

;!; ;!; ;!; ;!;

li! li! ~ ~ "' "' "' 115 ill g "' ,.........., "'

~ f.l~r:u:l • . ~J::r~-~ -···

;!;

li! IE "' ,..........,

"' s I ill I "' ~t;;ffi ~t;;ffi :ll;!;; :ll;!;; ,rs ,rs 12 . 12 .

;!; a;h iii~/;; ii! ;!; >< :bl~ :'2~ ~ li! 'ii! -(/]~ ><

"' li! li!~g!_ !!l Ill

LJ LJ LJ LJ LJ LJ ["] ["] ["] ["] ["] ["] ["] ["] • • • •

9~~~ Wlm 99~w. @~9 9~~~ ~~~9 9~~~ .....

u

~:::; u

~~ !:i !:i

• • • •

• • • • •

•

u

~!'.] !:i

• • • •

• ••••

S/N:=I ==;-~I -REY -

iw...... ... I/Cl IDn l OI OI OIOI OI O!OIOI e I/Iii•

~~-=l*tll•

NOTES: 1. INSTALLATION SHALL COMPLY WITH ALL APPLICABLE NATIONAL,

STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUMENTATION FOR ADDmONAL DETAILS

PRIOR TO INSTALLATION AND SITE PREPARATION WORK.

1HS mAWNl NID SPEafrATIONS HEREIN /1£. n£ PROPER1Y OF sctf4EIDER El..ECIRIC NID SHAU. NOT BE CCftD, REPRODUCm OR

USED IN WHCl.E OR N PART, ~ lHE BASIS RR n£ llNIUFACTIH: OR SALE OF llEMS Wl1HOUT IRllTEN PERMISSION FR<* SQINEIDER

El..EClRIC. lHIS DRAWING IS BASED ll'ON l.A1EST AVAll.lilll.E INRRMlDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE.

DIG MO: GVM 160KG65MODB 1 OR2 19'0 llRE: Galaxy VM

S h •d Input: 4lKJll I( 3PH DUALiSINGLI MAINS

C~'1el er 2YllJ.llN:iutis4B~~i!li=CABINEIS DRMNB\': NAGENDRA 10-SEP-15 NGLE v Electric uPS(sit«;LE/REDIMD.IHI] Mii' lfo OONaJS-2 a: l """D«HER: ____ c_.wmNJr ___ oo-r-1-o--s-EP-- -1s--1.PRWECTION t-PllnECl'--:-D_R_A_ W_l_N_G_ S....,....stm--1-411'-2-+1 _N'PllMD ___ ll\':_.--M- PAU-'-LS-EN-+--10---S-EP---15---1 N . A

• •I •O• .•. •O•I • • • • . . JlJlJ . . .. .

I I . . )C=:J CJ . . . . . . . . . )C=:J CJ :f/ . / . )C=:J CJ f{_; . F

/ - ~ - ~

I , ".,,. v 0 n -

I , ...... 0 =i 6l . . )C=:J CJ . . . . .... ..

)C=:J CJ . . . . . . JC=:J CJ c . . . . .

I I .. JC=:J CJ

.. . . . . :-)l)l) (

.

. . .

)l)l) . . . .. . .

)l}l) ... . . . • I I

e. I e )lJ ()/\ ';" 'k • -~

1• "J •O• ~~

-~ -~

•O•

LEFT SIDE VIEW {WITHOUT DOORS)

--- - ---..... / .... ,, '

( \ NB <a!Pm NUT ·-ri ' 0 ;'

' /

1)9-

•O•l: • ~

/

( ....

'.)

I ~BUS

NTERCDNNECTION BARS FOR

ADJACENT MODULAR mRY CABINETS BA

BB DC BREAKER

250A

,..--DC+

...--DC-BATTERY MONITOR

CONlROLlER-1 (REFER TO SHEET-16)

FRONT -

' ,....--P E

~ REFER TO VIEW-A (ENLARGED)

---- ---.....

~· ' 20] \ [~ 1'lf'

1'lf'

J ........_ _____ / ...

........_ _____ VIEW-A VIEW-B

(EN~RQEQ) {ENLARGED)

NQIES;_ 1. INSTAUATION SHALL COMPLY WITH ALL APPLICABLE NATIONAL, STATE AND LOCAL CODES.

FRONT VIEW

BB DC BREAKER 250A

BATTERY MONITOR CONTROLUER-2 (REFER TO SHEET-16)

5.24 [133] TYP

6.69 [170] ___ _,

INTERCONNECTION BUS BARS

3.03 [77]

48.75 [1238]

- ·

RIGHT SIDE VIEW {WITHOUT DOORS)

• O• • •

•

2. REFER TO PRODUCT DOCUMENTATION FOR ADDITIONAL DITAILS PRIOR TO ...--------------------......--------...--=:=-=-----------r=,,..,.,,,.....-----------r=r----t 1NSTAUAT10N AND s1TE PREPARATION WORK. 1HS mAWNi AND SPEaFrATIONS HEREIN ftl£. n£ PR0PER1Y OF 11RE: Galaxy w Diil MO· GVM 160KG65MODB 1 OR2 REV. O

3. ALL DIMENSIONS ARE IN INCHES [MH..UMETERS]. sctf4EIDER El..ECIRIC AND SHAU. NOT BE CCl'E), REPRODUCm OR s h .d Input: 4lKJll AC 3PH DUrMSINGLE MAINS • lH. MODULAR BATTERY (GVMMBTU) NOT PART OF THE SKU(GVMMOOBCWS), USED IN WHCl.E OR N PART, ~ lHE BASIS RR n£ llNIUFICllH: C o" e I er unnN/iutis 48~ ~~ = CABINETS DRMN Bl': NAGENDRA 10-SEP-15 HI R 0

SHOWN FOR ILLUSTRATION PURPOSE ONLY. OR SALE OF llEMS Wl1HOUT IRITTEN PERMISSION FR<* SQINEIDER Electric WIDE BATTERY CABINET INTERNAL 'l'IEW t-~----C-llNDlnl--,,,-DU--10---SE-P--1-5--1 NGLE 5. SOME STRUCTURAL DETAILS HAVE BEEN OMITTED FOR El..EClRIC. lHIS DRAWING IS BASED ll'ON LATEST AVAll.lilll.E 1----------......----+-~-----.......,......,--'-' --11-------f.

THE PURPOSE OF CLARllY. INRRMlDI AND IS SUlJECT TO OINIGE Wl1HOUT NOTICE. PRnECl": DRAWI NGS stm 1511'21 N'PllMD Ill': M PAULSEN 10-SEP-15 Pl!WEC1100

i------- 3.94 _____ ____. [100]

3.94 [100]

D

Dooo .. :'c:r =~ ,.=..

A OP3605AC

0 -SIMOR

SllNI' !IHllfl' M1Bft' JBJS MIJS 1111' 1fF CHET CMllS CM.IS

NEXT XR llllBS NEXT XR C&tET ClllllE'

BATTERY MONITOR CONTROLLER-1

3.94 t---- (100)--EFO-BAEll(ER--NJX.-!lllaj--------t

3.94 [100]

A OP3645AB

D

BATTERY MONlffiR CONTROLLER-2

NllJIS;_ 1. INSTALLAllON SHALL COt.4PLY WITH ALL APPLICABLE NATIONAL, STATE AND

LOCAL CODES. 2. REFER TO PRODUCT DOCUMENTATION FOR ADDfTIONAL DETAILS PRIOR TO

INSTALLAllON AND SITE PREPARATION WORK. 3. ALL DIMENSIONS ARE IN INCHES [MILLIMETER]. 4. BATTERY CABLING DIAGRAM SHOWN IS lYPICAL. 5. CABLES ARE PROVIDED BY SCHNEIDER El.£CTRIC. 6. CABLES IN CONTINUOUS LINE Will. BE CONNECTED IN FACTORY. 7. CABLES IN DASHED LINES (------)Wu.l BE CONNECTED BY SERVICE

ENGINEERS ON SITE. 8. EARTHING IS ESSENTIAL BEFORE STARTUP. 9. BATTERIES (G\/Mf.18TU) SHOWN ARE OPTIONAL AND NOT PART OF

SKUf G\IMMODBCWS. A10. FOR LATEST VERSION OF THE BOARD/S CONTACT SCHNEIDER ELECTRIC.

SHELf-12 {TOP)

SHELF-11

I LEFT LINE-UPI

d::J::J=l=l=l=l=l=l!;J~ d::J=l=l=l=l=l=l=l!;J~ dt--lt--lt--lt--lt--lt--lt--lt--l!;j~

I RIGHT LINE-UPI

LI LI

0 d=i=i=i=i=i=i=i=i!;Jw 0

0 d=l=l=l=l=l=l=l=l!;J~ 0 - dt--lt--lt--lt--lt--lt--lt--lt--l!;j~ -

dt--lt--lt--lt--lt--lt--lt--lt--l!;j~ dt--lt--lt--lt--lt--lt--lt--lt--l!;j~ LI LI

d::J=l=l=l=l=l=l::J!;J~ d=l=l=l=l=l=l=l=l!;lh:J SHELf-10

SHELf-9

SHELF-B

SHELf-7

SHELf-6

SHELf-5

SHELf-4

SHELf-3

SHELf-2

SHELf-1 (BOTTOf.1)

To NARROW BATT. CABINET

I I I I I

dt--lt--lt--lt--lf--if--if--il--j!;j~ dt--lf--if--if--if--if--if--il--j!;j~

dt--lf--if--if--if--if--if--il--j!;j~ dt--lf--if--if--if--if--if--il--j!;j~

dt--lf--if--if--if--if--if--il--j!;j~

dt--lf--if--if--if--if--if--il--j!;j~

dt--lf--if--if--if--if--if--il--j!;j~

dt--lf--if--if--if--if--if--il--j!;j~ dt--lf--if--if--if--if--if--il--j!;jif{J dt--lf--if--if--if--if--if--il--j!;j~

dt--lf--if--if--if--if--if--il--j!;j~ dt--lf--if--if--if--if--if--il--j!;j~

dt--lf--if--il--lf--if--il--lt--l!;;j~

dt--ll--ll--ll--ll--ll--ll--lt--l!;j~

d ::J =l =l =l =l ::J ::J ::J !;;! ~ ~...,...,...,...,...,...,...,...,§~ t--ll--ll--ll--ll--ll--ll--lt--l

dt--lt--lt--lt--lt--lt--lt--lt--l!;j~

c --88 ,-

I I ,,_.~ I

CABINET - -

To UPS

D D

D df--if--if--if--if--if--if--if--i!;j~ D n ldf--if--if--if--if--if--if--if--i!;j~ n

LI ldf--if--if--if--if--if--if--if--i!;j~ LI

D ldf--if--if--if--if--if--if--if--i!;jh:J D

D df--if--if--if--if--if--if--if--i!;j~ D n df--if--if--if--if--if--if--if--i!;j~ n

df--if--if--if--if--if--if--if--i!;j~ LJ LJ

D df--if--if--if--if--if--if--if--i!;j~ D

D df--if--if--if--if--if--if--if--i!;j~ D

D I d...,...,...,...,...,...,...,...,!;j~ D

LI I d...,...,...,...,...,...,...,...,!;j~ LI

D I d...,...,...,...,...,...,...,...,!;j~ D

0 I d...,...,...,...,...,...,...,...,!9l~ 0 D ldl--ll--ll--ll--ll--ll--ll--ll--l!;;j~ D

I d=i=i=i=i=i=i=i::J!;;I~ LI LI

D ' ~~~~~~~~~§~ D

0 0 n I d...,...,...,...,...,...,...,...,!;j~ n

c ,--BB

I ,-I I

~ I I I I I I I _____ J I

___l_L _____________ +~----J_L _____________ _ I I ~--------------~ ~---------------

To UPS

1HS mAWNl NID SPEafrATIONS HEREIN /1£. n£ PROPER1Y OF sctf4EllER El.ECIRIC NID SHAU. NOT BE CCftD, REPRODUCm OR USED IN WHCl.E OR N PART, ~ lHE BASIS RR n£ llNIUFICl'IH:

llRE: Golaxy w Diil MO: GVM 160KG65MODB 1 OR2 REV. O S h •d Input: 4lKJll AC 3PH DUrMSINGLE MAINS

OR SALE OF llEMS WlllWf IRll11EN PERMISSION FR<* SQINEIDER ElECIRIC. lHIS DRAWING IS BASED ll'ON LA1EST AVAll.lilll..E INRRM'IDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE.

c ~"el er 2 MODI&~~~\:~~~ ~~ACMIG DRMN Bl': NAGENDRA 10-SEP-15 NGLE v Electric WIDE BATIERY ooNET-CABLINc & PCB D«HER: c N«mJr oo 10-sEP-15 PRWECTION

l-PllnECl'--:-D_R_ A_ W_ l _N _G_S....,....stm--16_(1'_2-+1 -N'PllMD--ll\':-.--M- P_AU.._LS_EN ___ lO-- -SEP- -- ,-5 --1 N . A

/ ;

( ' '

NQIES:.

LEFT SIDE VIEW {WllHOUT DOORS)

,,,,.--- - - --- ' ' \ ;

1111 alWPED 1111 ( ·-o , 0 ;'

' / ..........._ ______

~

VIEW-A (ENLARGED)

/

'

FRONT -

BATTERY MONITOR CONTROUER-1

(REFER TO SHEET-18)

REFER TO VIEW-A (ENLARGED)

~----- ... '

~· \ ~ .H I

[Ml I M'

J /

..........._ ______ ~

VIEW-B (ENLARGED)

1. INSTAUATION SHALL COMPLY WITH ALL APPLICABLE NATIONAL, STATE AND LOCAL CODES.

FRONT VIEW

BB DC BRCAl<ER 25[).6.

& TIPICAI. BATIERY MOUNTING AREA

5.24 [133] TYP

6.69 [170] _____ ____,

INTERCONNECTION BUSBARS

3.03 [77]

48.75 [1238]

PE

REFER TO VIEW-B

(ENLARGED)

DC BUSBARS INTERCONNECTION BETWEEN TWO MODULAR B'.TTERY CABINETS/ BEIWEEN MODULA!l BATTERY CABINET AND UPS POWER CABINET

RIGHT SIDE VIEW {WITHOUT DOORS)

oo• e e

•

2. REFER TO PRODUCT DOCUMENTATION FOR ADDITIONAL DETAILS PRIOR TO .---------------------......--------"T"==-=-----------r=,,....,.,,,..-----------r=r----1 1NSTAUAT10N AND s1TE PREPARATION woRK. 1HS mAWNi AND SPEaFrATIONS HEREIN ftl£. n£ PROPERTY OF 11RE: Galaxy w Diil MO· GVM 160KG65MODB 1 OR2 REV. O

fl;: ~a~~~N~~~RYAR(~~M1:u~E~J:"if!~;s~E sKu(GWMoacNs). =~~ic,.ANiJk~ = :S.~~"i:w=:= Sch0neider 21;:~if\:!H~ml!A:: DRMN ~ ~ENDRA 10-sEe-1s H1Ro

SHOWN FOR ILLUSTRATION PURPOSE ONLY. OR SALE OF llEMS Wl1HOUT IRllTEN PERMISSION FR<* SQINEIDER Electric NARROW BATTERY CABINET-INTIRNN.. \llEW t-~----C-llNDlnl--,,,-DU--10---SE-P--1-5---1 NGLE 5. SOME STRUCTURAi. DETAILS HAVE BEEN OMITTED FOR ELECIRIC.. lHIS DRAWING IS BASED ll'ON LATEST AVAll.lilll..E 1----------......----+-~-----.......,......,--'-' --11-------f.

THE PURPOSE OF CLARITY. INRRMlDI AND IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE. PRnECl': DRAWI NGS stm 1711'21 N'PllMD Ill': M PAULSEN 10-SEP-15 Pl!WEC1100

3.94 [100]

A OP3605AC

6

5 D 4 .11117

0 lEMPERAlURE

2

3.94 [100]

Do D D -....... ..... ...... JDJI POIUBIOUT '°"""~ ......

TRIPllG OUT TRIPSIGIN --SHUNT SHUNT BATIERY ABUS lRIP TRIP CABINET CABLES

NEXT XR ADDRESS NEXT XR CABINET CABINET

BATTERY MQNITQR CQNTRQLLER

.tiQili. 1. INSTAl.ll\TION SHALL COMPLY WITH ALL APPLICABLE NATIONAL, STATE AND

LOCAL CODES. 2. REFER TO PRODUCT DOCUMEKTATION FOR ADDITIONAL DETAILS PRIOR TO

INSTAUATION AND SITE PREPARATION WORK. 3. ALL DIMENSIONS ARE IN INCHES [MIWMETER]. 4. BATIERY CABLING DIAGRAM SHOWN IS TYPICAL 5. CABLES ARE PROVIDED BY SCHNEIDER ELECTRIC. 6. CABLES IN CONTINUOUS LINE WILL BE CONNECTED IN FACTORY.

SENSOR

...... ..... .

ABUS CAllB

....

SHELF-12 I rl t---l t-l t-l t-l t-l t---l t-l t-l tj to (TOP) I rl t---l t-l t-l t-l t-l t---l t-l t-l tj to

I rl ...., t-J t-J t-J t-J ...., t-J t-J tj to SHELF-11 I rl t---l t-l t-l t-l t-l t---l t-l t-l tj to

SHELF-10 I rl t---l t-l t-l t-l t-l t---l t-l t-l tj to I rl ...., t-J t-J t-J t-J ...., t-J t-J tj to I rl ...., t-J t-J t-J t-J ...., t-J t-J tj to

SHELF-9 I rl t---l t-l t-l t-l t-l t---l t-l t-l tj to

SHELF-8

SHELF-7

I rl ...., t-J t-J t-J t-J ...., t-J t-J tj to I rl t-1 t-J r-j r-j r-j t-1 r-j r-j tj to I rl t-1 r-j r-j r-j r-j t-1 r-j r-j tj to I rl t-1 r-j r-j r-j r-j t-1 r-j r-j tj to

SHELF-6 I rl t-l r-j r-j r-j r-j t-l r-j r-j tj to I rlt---lt-J t-Jt-J t-Jt---lt-J t-Jt;;;J M

SHELF-5 I rl t-l r-j r-j r-j r-j t-l r-j r-j tj to I rl ...., t-J t-J t-J t-J ...., t-J t-J tj to I rl t-1 r-j r-j r-j r-j t-1 r-j r-j tj to

SHELF-4 I rl ...., t-J t-J t-J t-J ...., t-J t-J tj to I rl t-1 t-J t-J t-J t-J t-1 t-J t-J tj to

SHELhl I rl t-l r-j r-j r-j r-j t-l r-j r-j tj to I rl t-1 r-j r-j r-j r-j t-1 r-j r-j tj to

SHELF-2 I rl t-l t-l t-l t-l t-l t-l t-l t-l tj to SHELF-1 I rl t-l t-l t-l t-l t-l t-l t-l t-l tj to (BOTTOM) t-l r-j r-j r-j r-j t-l r-j r-j .---...

L.J==ttttt---, I

,---1 ,-1 I

I I I I I I

BB

To NEXT BA TT. CABINET

- - - - - ro WIDE BATT. CABINET : I

To NEXT -t-L _____________ _

BATT. I To 'MDE BATT. CABINET _1 _________________ _:ABINET

7. CABLES IN DASHED LINES {------)WILL BE CONNECTED BY SERVICE ENGINEERS ON SITE. r-==--::::-::::::::-:=:-::=::::-:=:-:-:::=-:=:-::-:::-==:='.""'.=--i---------,-=-:::---------~=--=------------.:==----I

a. EARTHING 1s ESSENTIAL BEFORE STARTUP. 1HS mAWNi NID SPEaFrATIONS HEREIN /1£. n£ PR0PER1Y OF llRE: Galaxy w Diil MO: GVM 160KG65MODB 1 OR2 RE.V.O 9. ~:Rl~L~~~c~~.' SHOWN ARE OPTIONAL AND NOT PAITT OF ~!rut~5?$ :=:·i:t~5 Scl}.."eider 21;;~i\:!H~ml!A:: '""DRMN==Bl':,..... __ NAG_ EN....,a_RA-+-_10_-s __ EP_-...;..1s'--I NGLE

.ti.10.FOR LATEST VERSION OF THE BOARD/S CONTACT SCHNEIDER ELECTRIC. ELECIRIC.. lHIS DRAWING IS BASED ll'ON l.A1EST AVAll.lilll.E V" Electric NARROW BATIERY C'AllNET-CABUNG &: PCB DRIER: c .wll&N/Y DU 10-SEP-15 PRWECTION INRRM'IDI NID IS SUlJECT TO ai'.NGE Wl1HOUT NOTICE. 1-:PllnECl'==:""'o--R,,..A,....W- I N- G----s ..... stm=-1 B--Cl'-2-11...;;N'PllMD...;....;;;;;.;;....ll\':_.__;_..;.;M..;.;P;;;;;AU:.;..LS..;.;EN-+--'1"'-0-...;;S..;.;EP __ .;..;;15--I N . A

INPUT & 480V JPH, 60Hz n J OR 4 WIRE+GROUND )MIB2 MIB1 65ki\ Rt.IS MAXIUUM l {PROl/IDED BY 01HERS) I

£ j L ___________ -----_______ &: _______ ---------1 I I

'BAnERY-=2B'BAnE"RY-=2A~~;· - · -l1!."Ps~2~.R~60KG6s~1/0~2- · T ·-· 'BAnERY-=1·B'BAnE"RY-=1·A~~;· - · -~p-~1~us~60KGs5ill 1/0~1 ·r · -·' (GVMMoaBcNs+ I (GVMMoaBcws+ l cABINET-2 T (oc-GVM1PR225KG65KJ (GVMMooscNs+ (GVMMooscws+ CABINET- 1 1 (DG-GVM1225K~5KJ I 2-GVMMBTU) 1· 12-GVMMBTU) 1· ( I rl 2-GVMUBTU) 12-GVMMBTU) ( I

/::\ /::\ 160kVA) 'f-.-< /::\ /::\ 160kVA) ili i ili i (OG-GVMP8160KG) L ~ ili ili (OG-GVMP8160KG) i

I ) UIB SSIB )

SBS

"'J' NEUTRAL BUS NEUTRAL BUS

T T T BATTERY BATTERY r UOB BA~RY TBATT~ : r

_L ~& . -+ .-::i . - . _L_. - . - . _L_. - . - . _L_. - . - . - . - . - . - . J_ ~~ . ~ ,GEC I I A. GEC I

L_ __ ___ _L__ _ ___L_ ____ _______ _

LI ! L_ _____ ---------------------------------i---_J --~---------------------------------i r-_____ _J

A.j ~-·r-NOTES: 1. INSTALLATION SHAll COMPLY WITH ALL APPLICABLE NATIONAL, STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUMENTATION FOR ADDITIONAL DETAILS PRIOR TO INSTALLATION AND SITE PREPARATION WORK. 3. DRAWING DEPICTS POWER SYSTEM CONNECTIONS AND IS NOT REPRESENTATIVE OF PHYSICAL LAYOUT,

PL.EASE REFER TO MECHANICAL DRAWINGS FOR PHYSICAL LAYOUT. Ll. 4. INPUT AC SOURCE TO BE 4aOV AC 3PH, 3 WIRE SYSTEM:-3 WIRE +GROUND,

4WIRE SYSTEM:-4WIRE +GROUND( CONTACT Schneider Electric IF OTHER). Ll. 5. AC CABLING TO BE 600V RATED, 3WIRE SYSTEM:-3 WIRE +GROUND, 4 WIRE SYSTEM:-4 WIRE+GROUND, PRO\llDED BY OTHERS. Ll. 6. BATTERIES (GVMMBTU) ARE OPTIONAL AND NOT PART OF SKU GVMMODBCW/GVMMODBCN.

BATTERY RUNTIME IS THEORETICAL AND CALCULATED BASED ON DATA PRO\llDED BY BATTERY MANUFACTURER ASSUMING OPTIMUM ENVIRONMENT AND LOAD CONDITIONS.

Ll. 7. BUSBAR LINKS APPLICABLE FOR SINGLE MAINS ONLY. SHOULD BE REMOVED FOR DUAL MAINS SYSTEMS.

I OUTPUT A_l 160kVA 1+1, 480V, 3PH ) 60Hz(SYNC. TO INPUT) r 3 OR 4 WIRE +GROUND

I I

' 8. LUGS ARE NOT PRO\llDED. SEE MECHANICAL SUBMITTAL PACKAGE AND INSTALLATION MANUAL FOR ADDITIONAL TERMINATION DETAILS.

Ll. 9. A GROUND BONDING JUMPER MUST BE CONNECTED TO THE "E" TERt.41NAL. GEC IS REQUIRED FOR 3 WIRE INPUT/OUTPUT ONLY.

Ll. 10. SYSTEM OUTPUT OCPD AND CABLING SHALL BE PROVIDED BY OTHERS. OCPD AND CABLING SHALL COt.4PLY WITH LOCAL OR NATIONAL CODE TAP RULES. SEE SHEET-21 FOR DETAILS.

11. OUTPUT GROUND FAULT DETECTION IS NOT PROVIDED FOR UNDERGROUND OR HRG INSTALLATION. CONTACT Schneider Electric FOR ASSISTANCE.

DEVICE RATING

UPS - INPlJT/DUTl'UT CABINET

DEVICE RATING rt"PE MAKE

UIB/ SSIB 4DOA, 6fXN N:, 4 POLE MCCB SCHNEIDER El.ECTRIC MBB I UOB

BATI'ERY CABINET

881/ 25G'., 500V DC 3 POLE MCCB SCHNEIDER El.ECTRIC 882

UOB

_J

MODEL

l.JF4&400CUJ1X

JDF3625D

lHIS mAWNl NID SPEaFICA~ HEREIN N£ 1l£ PROPERlY OF sctf4EllER El.ECIRIC NID SHAU. NOT BE COPED. REPRODUCED OR

USED IN WHCl£ OR N PART, NS lHE BASIS FOR 1l£ llANUFACME OR SALE OF llEMS WllHOOT WRIITTN PERMISSION FROM SCHNEllER

~~ut: 480 ~ ~NGLE MAINS DIG NO: GVM 160KG65MQDB 1 OR2 REV. 1 Sc'l.oeider 2 MOOiPtf.tf:u~~~orr~ ~=taNETS !MN&'(: twiENoRA/BALA 12-ocr-11 NGLE

ELECIRIC. 11115 DRAWING IS BASED ll'ON LATEST AVAll.lilll.£ llfmMTDI AN> IS SlalECI" TO aiNIGE Wl1HOUT NOTICE.

v Electric 1---SYSTE __ M_ o_N_E_u_NE---.01AG.--RAM ___ ENGNER: __ 1i1__.P/W_ z._/r_A/._A_ H-+--12_- _ocr_-_1_1 --1PROlCIDN PRnECT: DRAWi NGS stm 190f2 f.fPRCMD &'(: N lllllTT 12-0CT-17 N . A

INPUT 4a0\I 3PH, 60Hz

B'IPASS A 480\I JPH, 60Hz ill

J WIRE+GROUND 65kA RMS MAXIMUM (PROVIDED BY OlHERS)

3 OR 4 WIRE+GROUND l f 65kA RMS MAXIMUM •)01ei°) 8181 (PROVIDED BY OlHERS)

I I

I -~-=========================-1-_J I &: In., &I fn.:

iBATIERY-=-2slBATI-"ERY-=-2Alpo~~R· - -~Ps-2(GVM--;B160KG65slj !vo-=2 t - lBATIERY-1 BIBAnERY-1AlpowER - -~p~,~~60KG65~ ·1--vo=; t - l (GVMMODBCNS+ (GVMMODBCWS+

1 CABINET-2 r f0G-GVMIPR225KG65K) (GVMMODBCNS+ (GVMMOOBCWS+ CABINET-1 r ,(OG-GVM;t:KG65K)

/;).. /;).. I (160kVA) I /;).. /;).. ( 160kVA) I i-< ~ 1~ . rl ~ 1~ I

ill ~ . (OG-GVMPB160KG) ~ ill ill (OG-GVMP8160KG) L ~ I ) UIB SSIB ) ) UIB SSIB ) MBB )

I I

NOTES: 1. INSTMJATION SHM.L COMPLY WITH ALL APPLICABLE NATIONAL, STATE AND LOCAL CODES. 2. REFER TO PRODUCT DOCUt.iENTATION FOR ADDmONAL DETAILS PRIOR TO

INSTAUATION AND SITE PREPARATION WORK. 3. DRAWING DEPICTS POWER SYSTEM CONNECTIONS AND IS NOT REPRESENTATIVE OF PHYSICAL LAYOUT,

PLEASE REFER TO t.iECHANICAL DRAWINGS FOR PH'l'31CAL LAYOur. 64. INPUT AC SOURCE TO BE 4aOV AC 3PH, 3 WIRE+GROUND (CONTACT Schneider Electric IF OTHER).

MIB1 AND MIB2 COULD BE IN SEPARATE SOURCES. 65. BYPASS AC SOURCE TO BE COMMON 4BOV AC 3PH, 3 WIRE +GROUND OR 4 WIRE +GROUND.

THE BYPASS CONFlGURATION MUST MATCH OUTPUT CONFIGURATION. BIB 1 AND BIB2 MUST BE IN SAME SOURCE. 66. AC CABLING TO BE 600V RATED, 3 WIRE+GROUND, PROVIDED BY OTHERS. 67. AC CABLING TO BE 600V RATED, 3 WIRE SYSTEt.i:-3 WIRE+GROUND, 4 WIRE SYSTEM:-4 WIRE+GROUND, PROVIDED BY OTHERS. 68. BATTERIES (GVMMBTU) ARE OPTIONAL AND NOT PART OF SKU GVMMODBCW/GVMMODBCN.

BATTERY RUNTIME IS THEORETICAL AND CALCULATED BASED ON DATA PROVIDED BY BATTERY MANUFACTURER ASSUMING OPTIMUM ENVIRONMENT AND LOAD CONDITIONS.

69. BUSBAR LINKS APPLICABLE FOR SINGLE MAINS ONLY. SHOULD BE REMOVED FOR DUAL MAINS SYSTEMS. 10. LUGS ARE NOT PROVIDED. SEE MECHANICAL SUBMITTAL PACKAGE AND INSTALLATION MANUAL FOR ADDmONAL TERMINATION DETAILS.

611. A GROUND BONDING JUMPER MUST BE CONNECTED TO THE "E" TERMINAL GEC IS REQUIRED FOR 3 WIRE INPUT/OUTPUT ONLY.

12. CABLE LENGTHS FOR STATIC BYPASS INPUT SHAl.1 BE SAME SUM TOTAL TO ENSURE CORRECT LOAD SHARING IN STATIC BYPASS OPERATION.

613. SYSTEM OUTPur OCPD AND CABLING SHAl.1 BE PROVIDED BY OTHERS.

I I

'

OUTPUT 160kVA 1t 1, 480V, 3PH 60Hz(SYNC. TO BYPASS) 3 OR 4 WIRE +GROUND

DEVICE RATING

UPS - INPlJT/DUTl'UT CABINET

OE\llCE RATING l"t'PE MAKE MOOE!.

UIB/ SSIB 400A, 6fXN N:, 4 POLE MCCB SCHNEIDER El.ECTRIC l.JF4&400CUl1X MBB I UOB

BATI'ERY CABINET

881/ 25G'., 500V DC 3 POLE MCCB SCHNEIDER El.ECTRIC JDF36250 BB2

OCPD AND CABLING SHALL COMPLY WITH LOCAL OR .--lH-IS-mAWNl--Nl-D-SPEa--~-~--H-EREl-N-N£-ll£--PROPERlY---OF-..---------..,llll£:='"". ----------r=DIG=""'NO:,,,....-----------.RE.Y==---t NATIONAL CODE TAP RULES. SEE SHEET-21 FOR DETAILS. sctf4EllER El.ECIRIC NID SHAU. NOT BE COPED. REPRODUCED OR Input: 460 ~H,UAL MAINS GVM 160KG65MQDB 1 OR2 ' 1

14. oUTPUT GRouND FAULT DETECT10N 1s NOT PROVIDED FoR usm 1N WHCl£ OR ,. PART, NS lHE llASls FOR 1l£ llANUFACME Sch0neider output· 4Bov AC 3PH 1sokvA ENoRA/ 12 ocr 17 NGLE

UNDERGROUND OR HRG INSTAUATION. OR SALE OF nEMS WllHOOT WRIITTN PERMISSION FROM SCHNEllER El t . 2 llOOIA.E 1+1 ·uPS Wl1H MODUL'Jl 81.lTERY CABNETS IMIN Br: NAG BALA - -CONTACT Schneider Electric FOR ASSISTANCE. ELEC1R1C. lHIS DRAWING IS BASED ll'ON LATEST AVAll.lilll.£ ec rlC 1----SYSTE __ t.i_O_N_E_U_NE_ DIAG...-RAt.i ____ ENGNER: ___ M_P._/W__.Z/r_ A/._A_H-+--12_-_0CT_ -_17---1PROlCIDN

llfmMTDI AN> IS SlalECI' TO aiNIGE Wl1HOUT NOTICE. PRnECT: DRAWi NGS stm 200f2 f.fPRCMD Br: N lllllTT 12-0CT-17 N . A