Induction Presentation C02

Welcome

HEALTH, SAFETY & ENVIRONMENTAL

INDUCTION(738-C02)

Client : ROYAL COMMISSION Principle Contractor : KIFAH CONTRACTING COMPANYSite Reference : 738-C02Location : JUBAIL INDUSTRIAL CITYProject Manager : Mr. AMR Mahmoud NaguibEH&S Manager : Mr. Shamim Ahmad Siddique

SITE INFORMATION

Organization objectiveThe main objective of our department is to have ZERO accident at site. Create Safe working Environment. Implement safety culture. To complete the project with ZERO accident.

Policy

About Us……

HSE Manager Shamim Ahmad Siddique

HSE Engineer Faiz Ahmed

Safety OfficerMd Irshad Ali

Shaikh Aashiq Ali

Shaik Mohammad

Masood ShaikPrajith K. R.Manu M. P.

Tank Area Telecommunication Building

PROJECT?

WHY ACCIDENT ? Safety Procedure not followed. Proper PPEs missing. Shortcuts at work. SLIP & Trip due to obstruction & wet surface.

Incompetency.

Basic Reason……..

Color CodeJANUARY - MARCHv

APRIL - JUNE

JULY - SEPTEMBER

OCTOBER - DECEMBER

Signage

Warning Sign giving warning of a hazard or danger.

Prohibited A sign prohibiting behavior likely to increase or cause danger.

Mandatory A sign prescribing specific behavior to followed.

Emergency Sign giving information on emergency exits, first aid, or rescue facilities

Red-man & Green-man

Persons operating within 02 - 10 meters

Persons operating beyond 10 meters

Dead man - Person operating within 0-2 meters

Personal Protective Equipment (PPEs)

Mandatory PPEs

PPEs Related To Work

Hot Work

Working at Height

Unsafe Act

Unsafe Condition

Electrical SafetyOnly qualified electricians shall perform

the job. Never use defective electrical

equipment's, defective extension cords or shop made equipment's.

All electrical conductors shall be considered energized unless notified.

Use 110 V for all portable electrical tools.

No work on exposed live conductors. Metal ladders shall not be used.

DIFFERENCES IN TOOLS

110 VOLT 220 VOLT

Do Not Use…….

Bad Practice

XX

ScaffoldAll Scaffolding must be inspected by Trained Competent

Scaffolding Inspector before they can be used.

Complete guardrails and other fall protection arrangements shall be made for platforms above 1.8 m.

It must contain Guard-rail, Mid-rail & Toe-board.

Use ladder for access & egress while using scaffold.

Always check for SCAF-TAG before using.

Use Body Harness above 1.8 m.

XAccepted Not Accepted

Safe for UseBody Harness Required Do Not Use

Scaf-Tag

Welfare Facilities

Drinking Water.Rest Area.

Smoking Area.Toilet & Ablution.

Water Station

Cool & Sweet drinking water provided at site.

Rest Area

Toilet & Ablution.

Smoking Area

Recycle Area

Separate Skip for• Wood• Steel• Polythene

Ladder Aluminum and steel ladder

always maintain three points of contact

Don’t carry tools, equipment, or material in your hands while climbing

If more than 3 metres or 10 feet up, wear a safety harness.

Unsafe use of Ladder

Wooden ladder is strictly prohibited at site.

X

EMERGENCY CONTACTCall 0580290327 OR Ext. 9601 (PROJECT MANAGER) 0599748039 OR Ext. 9606 0592760385 (SAFETY DEPARTMENT) 0597391457 OR Ext. 9611 (MALE NURSE/ FIRST AID) 0597391457 (AMBAULANCE DRIVER)

From phone/mobile call. Say, “This is an EMERGENCY”. Describe the incident location. Describe the incident. Report injuries, if any. Give your name and other details. Stay on line until further instructed.

EMERGENCY PROCEDURE

Know the Assembly Areas. In case of emergency, stop your

work and rush to the assembly area.

Be there until advised to move. Participate in Roll Call / Head

count. Look for your co-workers.

ASSEMBLY AREA

DRIVING AT SITE

Speed Limit (Km/Hr) Seat Belt

It is the responsibility of the driver to ensure his vehicle is safe to operate.

Only Valid Saudi Government driving license. The driver is responsible for transporting the

materials properly and ensuring that a load does not exceed the manufacturer’s design load capacity.

Follows the traffic rule at site. Watch for the people moving in pedestrian and

crossing point. Park your vehicle in parking area ONLY. Do not leave vehicle in start condition.

Rules……...

Observe

Identify the Hazards

Tie-Back GateHarness Leg Straps

Improper Tie-Off Location

Proper Tie-Off LocationStanding on Scaffold Tube

Sitting on Railing Not Allowed

Knot in Lanyard

No Tie-Off

Extinguisher Not Secured

Housekeeping

Thank you.

Prepared By,

Faiz Ahmed(HSE ENGINEER)