View
219
Download
4
Category
Preview:
Citation preview
PRIME INSPECTION AND TESTING SERVICES LTDLifting Appliances, Lifting Gears & NDT specialists
……….Redefining inspectionOffice Address: 32, Oduwole street Egbeda-idimu road, Egbeda, lagos
Tel. No.: 08033433390, 08087874241
Equipment Inspection Certificate
CLIENT 1 AMBER RESOURCES NIGERIA LIMITEDLOCATION 1 LADOL, APAPA PORT, LAGOSITEM `1 AIR COMPRESSORFLEET CONTROL No.: 1 CO -907MANUFACTURER 1 INGERSOLL RANDDATE MANUFACTURED 1 2003CAPACITY 1 1300 CPM @ 150 PSI, 614 L/S @ 10.3 BARMAX PRESSURE 1 225 PSIAIR TANK MWP 1 250PSI @ 300FRELIEF VALVE SET PRESSURE
1 180PSI( 12 Bar) AS OBSERVED WHILE IN OPERATION
ENGINE MAKE/RPM 1 CATERPILLAR/1800 RPMDATE OF SURVEY 1 20/03/2013VALIITY 1 6 MONTHS 19/09/2013( Factories Act of Nig.
1990 sec 26(2)
VISUAL INSPECTIONA thorough pre/post load visual inspection was conducted and was found to be in satisfactory conditionFUNCTION TESTConducted while the equipment was in operation and found satisfactory with up to 180 PSIG pressure output while the engine RPM was 1800 at normal temperature and sound. All the functions units and accessories were in order. There were no leakages of any sort.CONCLUSIONThe entries above on this AIR COMPRESSOR located at the above address which was tested by PRIME INSPECTION AND TESTING SERVICES LIMITED ARE facts and meets the minimum standard. Hence it is certified fit for use within its normal operational parameters provided no major mechanical repairs or any alterations are carried out on the equipment without the prior knowledge of the undersigned
INSPECTOR: James Isik
20/03/2013 SIGNATURE/DATE
Approved By: Charles Onyechere
Equipment Inspection ReportAIR COMPRESSOR(AMBER CO-907)
CONDITION OF ACCEPTABLE REMARKENGINE YES NO N/AVisibly check oil hoses for leaks YES OKCheck fan belt tension YES OKInspect engine mounts YES OKIts engine exhaust clean YES OKIts flame arrestor fitted YES OKAIR TANK YES OKIs it in good condition YES OKIs it marked with SAFE MAX WP YES OKHas it suitable pressure relief valve YES OKIs the relief valve working normally YES OKPANEL LIGHTS YES NO N/A OKAll light bulbs are operational YES OKBODYWORK YES NO N/A REMARKAre all guards fitted YES OKDoes tailgate hook properly YES OKFUEL TANK YES NO N/A REMARKIs it in good condition YES OKAre there any fuel leaks NO OKCabin(Switch Panel) Are they working YES NO N/A REMARKDoes the running hour speedometer work YES OKDo indicators( Temp & Pressure & Battery switches work)
YES OK
AIR( Suction M/F, Drier/Accumulator YES OKAir( Compressor Loading & Discharge) control valves
YES OK
IGNITION SWITCH/STARTER KEY YES OKDOORS, Do they close properly YES OKBattery(Are they in good condition) YES OKElectrical cables( Power & Controls) Are they in order
YES OK
Recommended