View
6
Download
0
Category
Preview:
Citation preview
1
SCHEME OF MINING
(Submitted Under Rule 18(2) of M.D.C.R. 2002)
OF
BALDEVGARH MARBLE MINE, M. L. No. 160/87
VILLAGE- BALDEVGARH, TEHSIL- RAJGARH
DISTRICT- ALWAR, STATE- RAJASTHAN
TOTAL LEASE AREA- 1.00 Hect (NON-FOREST LAND)
LEASE PERIOD 20 YEARS (23/04/1988 TO 22/04/2008)
UNDER 1st RENWAL 20 YEARS W.E.F. 23/04/2008
Lessee Prepared By
Manoj Kumar Sharma
S/O Sh. Kailash Narayan Sharma
107, Vyas Mohalla, Ward no. 22,
P.O. Dausa- 303303,
Distt. Dausa (Rajasthan)
Arun Kumar Yadav Reg. No. RQP/AJM/242/2003/A, Overseas Min Tech Consultant
ISO 9001:2008 Certified 501, 5th floor, Apex Tower, Tonk Road, Jaipur-302015
Tel. No. 0141-2744509 Mobile No.-9460221084
E-Mail- arun.omtc@gmail.com Website- www.overseasmintech.com
2
MANOJ KUMAR SHARMA MINES OWNER
S/O Shri Kailash Narayan Sharma,
R/O 107, Vyas Mohalla, Ward no.22,
P.O. Dausa -303303 (Raj.)
AUTHORISATION
I, Manoj Kumar Sharma, hereby authorise Shri Arun Kumar Yadav RQP No.
RQP/AJM/242/2003/A to prepare the Scheme of Mining under Rule 18(2) of MDCR,
2002 in respect of Baldevgarh Marble Mine, M. L. No. - 160/87 over an area of 1.00 hect
for mineral Marble in Village Baldevgarh, Tehsil Rajgarh, District Alwar, State Rajasthan
of Shri Manoj Kumar Sharma R/O Dausa.
I request the Superintending Mining Engineer, Department of Mines & Geology,
Jaipur to make further correspondence regarding modification / withdrawal / re-
submission and to collect the approved copies of the aforesaid Scheme of Mining with the
said recognized person on his following address: -
Arun Kumar Yadav
Reg. no.-RQP/AJM/242/2003/A
Validity 21 St May 2023
Address of RQP-501, Apex Tower,
Tonk Road, P.O. Jaipur-302015 (Raj.)
E-Mail- arun.omtc@gmail.com
Website- www.overseasmintech.com
Telefax - 0141-2744509(O), M - +91-9460221084
Place : (Manoj Kumar Sharma)
Date : Lessee
3
ARUN KUMAR YADAV
AMIE (Mining), FCC [Metal (R)], RQP, Surveyor (Coal & Metal), FAE (NV&RH)
501,5th Floor, Apex Tower, Tonk Road, Jaipur- 302015,
Telefax No. - +91-141-2744509, Mobile No – 9460221084,
E-Mail- arun.omtc@gmail.com, Website- www.overseasmintech.com
CERTIFICATE
I, Arun Kumar Yadav, hereby certify that,
1. “The provisions of Rajasthan Minor Mineral Concession Rules, 1988 have been
observed in the Scheme of Mining for Baldevgarh Marble Mine M. L. No. - 160/87 over
an area of 1.00 hect for mineral Marble in Village Baldevgarh, Tehsil Rajgarh, District
Alwar, State- Rajasthan of Shri Manoj Kumar Sharma and wherever specific permission
is required the lessee will approach the concerned authorities of Department of Mines &
Geology for granting the permission.”
2. It is also certified that the provisions of Mines Act, Rules and Regulations made
there under have been observed in the aforesaid Scheme of Mining and wherever specific
permissions are required the lessee will approach the Director General of Mines Safety.
3. It is further certified that the aforesaid Scheme of Mining is prepared as per the
copies of the records and documents provided by lessee and information given as per
discussions held with Lessee’s representative.
4. It is also certified that the information furnished in the aforesaid Scheme of
Mining are true and correct to the best of my/ our knowledge & belief and in case of
default the approval would be withdrawn.
5. It is also certified that the plans and sections are prepared based on the lease map
authenticated by the State Governments.
Place : Jaipur
Date : (Arun Kumar Yadav)
RQP/AJM/242/2003/A
Validity 21 St May 2023
4
MANOJ KUMAR SHARMA MINES OWNER
S/O Shri Kailash Narayan Sharma,
R/O 107, Vyas Mohalla, Ward no.22,
P.O. Dausa -303303 (Raj.)
CERTIFICATE 1. It is certified that the provisions of Mines Act, Rules and Regulations made there
under have been observed in the Scheme of Mining for Baldevgarh Marble Mine M. L.
No. - 160/87 over an area of 1.00 hect for mineral Marble in Village Baldevgarh, Tehsil
Rajgarh, District Alwar, State Rajasthan of Shri Manoj Kumar Sharma and wherever
specific permissions are required, the lessee will approach the Director General of Mines
Safety. Further, the standards as prescribed by DGMS in respect of miner’s health will be
strictly implemented.
2. The Scheme of Mining for Baldevgarh Marble Mine M. L. No. 160/87 over an
area of 1.00 hect for mineral Marble in Village Baldevgarh, Tehsil Rajgarh, District
Alwar, State Rajasthan of Shri Manoj Kumar Sharma complies all the statutory Rules,
Regulations, Orders made by the Central Government or State Government, Statutory
organizations, Court etc. and have been taken into consideration. Wherever any specific
permission is required, the lessee will approach the concerned authorities.
Place : (Manoj Kumar Sharma)
Date : Lessee
5
MANOJ KUMAR SHARMA MINES OWNER
S/O Shri Kailash Narayan Sharma,
R/O 107, Vyas Mohalla, Ward no.22,
P.O. Dausa -303303 (Raj.)
DECLARATION
1. The Scheme of Mining for Baldevgarh Marble Mine M. L. No. - 160/87 over an
area of 1.00 hect for mineral Marble in Village Baldevgarh, Tehsil Rajgarh, District
Alwar, State Rajasthan of Shri Manoj Kumar Sharma has been prepared in full
consultation with me and I understand its contents and agree to implement the same in
accordance with law and in case of default the approval would be withdrawn.
2. It is further declared that during the pendency period of the approval of above said
document or thereafter if any change occurs in the name and address of lessee, it will be
informed promptly.
Place : (Manoj Kumar Sharma)
Date : Lessee
6
MANOJ KUMAR SHARMA MINES OWNER
S/O Shri Kailash Narayan Sharma,
R/O 107, Vyas Mohalla, Ward no.22,
P.O. Dausa - 303303 (Raj.)
UNDERTAKING
1. I, Manoj Kumar Sharma, lessee for Baldevgarh Marble Mine M. L. No. 160/87
over an area of 1.00 hect for mineral Marble in Village Baldevgarh, Tehsil Rajgarh,
District Alwar, State Rajasthan of Manoj Kumar Sharma hereby undertake that all the
commitments so made in the aforesaid Scheme of Mining by the RQP Arun Kumar Yadav
to be deemed to have been made with my knowledge and consent and as such shall be
acceptable to me and binding on me in all respects.
2. I, Manoj Kumar Sharma, lessee for Baldevgarh Marble Mine M. L. No 160/87
over an area of 1.00 hect for mineral Marble in Village Baldevgarh, Tehsil Rajgarh,
District Alwar, State Rajasthan of Manoj Kumar Sharma hereby also undertake that all the
measures proposed in this Scheme of Mining will be implemented in a time bound
manner from the date of approval of this Scheme of Mining as proposed.
Place : (Manoj Kumar Sharma)
Date : Lessee
7
LIST OF ANNEXURES
S. No. Particulars Annexure No.
1 Photo Id along with address Proof 1
2 RQP Certificate 2
3 Copy of Transfer Deed 3
4 Copy of Renewal application 4
5 Site Plan 5
6 Demarcation Report 6
7 Khasra Map 7
8 Jamabandi 8
LIST OF PLATES
S. No. Particulars Plate Number
1 Key Plan 1
2 Location Plan 2
3 Surface Plan & Sections 3
4 Surface Geological Plan & Sections 4
5 Year wise development Plan &Section 5
6 Conceptual Plan 6
7 Environment Plan 7
8
INDEX
CHAPTER TITLE PAGE NO.
1 General information about lessee 9
2 Details of the mining lease 10
3 No. of exiting mining pits, their dimension and location,
Plan & section of the pits, brief geology of the area
12
4 Details of production and dispatches of last 5 years 16
5 Physical & geological Characteristics of the deposit 16
6 Details of the mining machinery deployed or to be deployed
and their detailed specifications
17
7 Method of Mining 18
8 Year wise annual programme of mining for next 5 years 24
9 Details of employment 24
10 Measure taken and to be taken for land restoration,
reclamation And plantation in/ or nearby lease area
25
11 Measure taken and to be taken for protection of
environment in And around mining area
26
12 Measure taken and to be taken for Dumping overburden,
stacking of top soil and utilization of top soil
29
13 Measures taken and to be taken for the control of water,
noise and Air pollution
30
14 Contribution regarding the social development of the nearby
resident
32
15 Details of health checkup and insurance of all the employed
persons (for existing lease/QL)
34
9
CHAPTER – 1
1. General Information about Lessee: -
(a) Name and address of Lessee
Shri Manoj Kumar Sharma
S/O Shri Kailash Narayan Sharma,
R/O 107, Vyas Mohalla, Ward 22,
P.O. Dausa- 303303 (Raj.)
(b) Status of the Lessee: -
Individual
(c) Name & Address of authorized person, who has prepared the Scheme of
Mining:
ARUN KUMAR YADAV
RQP / AJM / 242 /2003 / A
Valid Date– 21st May 2023
501, 5th floor, Apex Tower,
Tonk Road, P.O. Jaipur-302015
E-Mail- arun.omtc@gmail.com
Website- www.overseasmintech.com
Tel. No. 0141-2744509(O), Mobile No.-9460221084
10
CHAPTER – 2
2. Details of the Mining Lease a) M. L. No. 160/87
b) Name of the Mineral: - Marble (Khanda)
c) Demarcation report of the mining lease with plan (Copy Enclosed for Sanction
Order/Transfer deed/Renewal Application: - Annexure No. 3,4,5 & 6
Demarcation Report (Annexure No. 6)
From To Bearing Distance (in m.)
F.R.P. Well A 18˚00' 40
A B 275˚00' 100
B C 5˚00' 100
C D 95˚00' 100
D A 185˚00' 100
FRP- Well of Shri Chandanath Jogi, Latitude- 27008'32.13'', Longitude- 76022'59.36''
d) Key Plan of the area: - Plate No. 1
e) Location Map of the Mining lease, showing the details of the approach roads up to the
area: - Plate No. 2
f) Details of the Mining Lease: -
Near Village: - Baldevgarh Tehsil: - Rajgarh District & State: - Alwar, Rajasthan Area: - 1.00hect.
Khasra No. 226 & 473 Period: - 20 Years lease period w.e.f. 23/04/1988 to 22/04/2008 has
completed and lessee has applied for 1st renewal for further
20 years from 23 April 2008 to 22April 2028.
11
Infrastructure Facilities: -
2.2.1:- Railway Station: - The nearest railway station is Rajgarh(B.G.)on Alwar-Mathura
section of North Western Railway which is located at 30 km. from mine site.
2.2.2:- Police Station: - The nearest police station is Tehla which is about 18 km. from
mine site.
2.2.3:- Post Office: - The nearest post office is at village Baldevgarh which is about 1.5
kms from the mine site. The telephone facilities are also available at Baldevgarh.
2.3.4:- Medical Facilities: - Govt. primary health centre is available at Baldevgarh
whereas the nearest hospital is at Rajgarh.
2.3.5:- Availability of water: - Water for drinking purpose is brought from village
Baldevgarh. The water of hand pump and a well located nearby the M. L. area is potable.
Water required for dust suppression is being brought from the well by water tankers on
hire basis.
2.2.6:- Electricity: - There is no electric line passing through the mine area .The mining
and mineralized area is about 1.5 km. away from Village Baldevgarh where electric line is
available. Electricity required for mining is being supplied by JVVNL.
2.2.7:- Educational Facilities: - The primary & secondary school facilities are available
at village Baldevgarh whereas college is at Rajgarh.
2.2.8:- Mode of transportation of Mineral: - The mine site is approachable by Alwar-
Rajgarh- Tehla- Baldevgarh metalled road (Plate No.2, Location Plan). M. L. area is about
1.5 kms from the village Baldevgarh approachable by fair weathered road. Mineral is
being transported by trucks/dumpers from mine site to end user.
2.3.9:- River/ Canal: - There is no river and nalah falling within 5 kms radius of the lease
area.
2.3.10:-Port:-The nearest port is Kandla port which is about 850 kms from the mine site.
12
2.3.11:- Other relevant information: - Banking and all other facilities are available at
Rajgarh.
CHAPTER – 3
GEOLOGY
No. of existing Mining Pits: - One
Dimension: - Pit no. 1:-. Length: - 87 m., Width: - 82 m., Depth: - 24 m.
Location: - 00-101N to 4E-47W
Surface Geological Plan-Plate No.-4
a) Physiography & Drainage:- The lease area is located 1.5 Km. due north of village
Baldevgarh. The area, for which Scheme of Mining is prepared, is plain area. The lease
area is occupied by Dolomitic Marble and Alluvium. The highest altitude is of 338.7 mRL
and the lowest altitude is of 314.2 mRL in pit bottom of the lease area. So the level
difference is of 24.5 m.
General drainage pattern is North East- South West.
The area consists of scanty bushes and trees of Babool & Khakra. Thorny bushes have
also grown up in the area. The tree density is 15 trees per hectare and average girth of the
trees is not more than 0.15 meter. Maize, Wheat, Bajra and Pulses are the major crops of
the region.
There is no protected or reserved forest in and around the lease area.
There is no habitation within the lease area.
Vegetation
The lease area is having few local bushes only.
Climate
The area is characterized under semi arid type with an average annual rainfall of about
565 mm. which is mainly, received during July to September. The area is categorized as
Semi Arid zone.
Minimum Temp. - Varies between 1.4º during winter and 30º C in summer.
Maximum Temp. - Varies between 25º during winter to 47º C in summer.
13
b) Geology of the area
i) Regional Geology
The district comprises Precambrian metamorphic and igneous rocks, belonging to
the Mangalwar Complex of the Pre-Delhi (Archean) and Raialo, Alwar and Ajabgarh
Groups, in ascending order of superposition, belonging to the Delhi Super group (Lower
to Middle Proterozoic) and post-Delhi igneous intrusive Alluvium and Aeolian sediments
mark the older formations. The Mangalwar Complex comprising quartzite, mica schist,
crystalline limestone, conglomerate and granite, occur as isolated exposures in the
southern part.
These are un-conformably overlain by the Raialo Group comprising
predominantly calcareous formations with volcanic and subordinate quartzite. These lie in
the core part of regional folds, defined the main structural pattern of the area and contain a
basal conglomerate and arkose quartzite unit, followed by a sequence of argillaceous and
impure calcareous rocks.
The geological sequence worked out by G.S.I. is given as under.
14
ii) Local Geology: -
Geologically, the rocks of Railo group are outcropping in the mining lease area.
The common rock type of this area is Dolomitic Marble. The stratigraphic sequence of the
litho unit present in the area is as follows: -
Recent & sub recent - Alluvium
Delhi Super Group - Railo Group – Dolomitic Marble
To understand the structural configuration of the lease area, a surface geological
plan has been prepared on a scale of 1:1000. Geological cross-sections are drawn along
with longitudinal section.
C) Method of Estimation of Reserves
Based on the working of the deposit and occurrence of Marble at various places, it
reveals that the complete lease area is mineralized. Accordingly, the marble reserves have
been estimated on following considerations: -
15
(i) Average 0.15 m thick cover has been considered as overburden scree
material.
(ii) Average 17 m thickness as exposed Marble (Khanda) has been considered under
proved category of reserves.
(iii) A further 20 m depth of Marble (Khanda) below proved category has been
considered under probable category reserves.
(iv) Another 10 m depth of Marble (Khanda) below probable category has been
considered under possible category reserves.
(v) Bulk Density of Marble (Khanda) has been considered 2.7 tonnes /m3.
(vi) Recovery of Marble (Khanda) is taken 95% of total reserve.
Reserve estimation: -
The reserves have been estimated considering the experience gained for the last
25 years of mining of marble and its exposures. The reserves for Marble under proved,
probable & possible categories have been calculated by cross- sectional area method.
I Proved Reserves:
= Cross- Sectional Area (m2) x influence length (m) x Bulk Density (t/m3)
= 404 x 100 x 2.7 x 0.95
= 103626 MT
II Probable Reserves:
= Cross- Sectional Area (m2) x influence length (m) x Bulk Density (t/m3)
= 2002 x 100 x 2.7 x 0.95
= 513513 MT
III Possible Reserves:
= Cross- Sectional Area (m2) x influence length (m) x Bulk Density (t/m3)
= 1000 x 100 x 2.7 x 0.95
= 256500 MT
Total Geological Reserves = (Proved + Probable + Possible) reserves
= 103626 + 513513 + 256500
= 8,73,639MT
16
Mineable Reserve
For estimation of mineable reserve the following parameters have been taken into
consideration: -
i) Recovery of Marble is 95%, 5% is Mining Loss of total reserve.
(iii) Waste Rocks (OB) = Nil
Life of mine
We are considered average production of 90,000.0 MT of Marble (Khanda) per
annum from the mine.
Life of mine = Total mineable reserve/ Av. Annual Production
= 8,73,639/ 90,000
= 9.7071
= Say 10 years
CHAPTER-4
DETAILS OF PRODUCTION AND DISPATCHES OF LAST FIVE Y EARS: -
The details of Production and dispatched of last five years are as follows:-
BLOCK KHANDA
Year Production Dispatches Production Dispatches
2008-09 0 0 56931 56931
2009-10 0 0 40110 40110
2010-11 0 0 232646 232646
2011-12 0 0
2012-13 0 0
17
CHAPTER-5
Physical & Geological Characteristics of the deposit
Structure - Massive
Texture - Granulose
Color - White and light bluish
Form - Crystalline
Luster/Glose - Dull
Transparency - Quartz grains opaque
Hardness - 3.5 to 3.8 on Mohr’s scale
Specific gravity - 2.7
CHAPTER- 6
Details of the Mining Machinery deployed or to be deployed and their detailed
Specifications: - The following Mining Machinery deployed at Mines.
S. No. Machine No’s Make Capacity
1 Drill Machine 1 Atlas Copco 32mm
2 Dumper / Tipper 1 Ashok Leyland 8Te
3 Tractor mounted compressor 1 CPT 360CFM
The Machinery to be deployed and their Specifications are as follows: -
18
S. No. Machine No’s Make Capacity
1 Drill Machine 1 Atlas Copco 32mm
2 Excavator cum loader 1 L&T 1.2 m3
3 Dumper / Tipper 2 Ashok Leyland 8Te
4 Diesel operated pump 1 Local 5Hp
5 Jack hammer 1 Atlas Copco …
CHAPTER- 7
METHOD OF MINING
Present method of mining: -
It is a working lease for the last 25 years. The mineral marble (Khanda) is being won
by open cast mechanized method of mining by forming benches each of 6 m. height &
width in a single pit of the size 87m (length) x 82m (width) x 24m (depth). The work is
being carried out by using jack hammer and compressor for drilling the holes of 32 mm
dia. & controlled blasting with ANFO and primary cartridge to form big boulders, which
are further broken by manual hammer to form marble Khanda.
Proposed Year wise development for next four Years: -
19
The opencast method of semi mechanized mining is proposed for excavation of
marble (Khanda). The scheme of mining will be from 2013-2018.Actual work carried out
during 2013-14 has been given and proposal for the remaining period has been made.
The year-wise plan, sections and position of the pit at the end of each year have
been given in Plate No. 5.
During the period of first year 2013-14 actual production achieved were-----,
Overburden removed------, Plantation carried out---- etc.
During the period of second year (2014-15), it is proposed to develop two benches
in Marble (Khanda) mine. The work will be carried out along the section, X-X' at 331,
317 and 311 mRL benches shown on Plate No. 5. Haul roads are proposed upto the face
and loading will be done from face itself. No mineral stack yard is required. Plantation
will also be done as shown on plate no.-5. The details of total waste rock handling during
this year are given in Table 7.1.
During the period of third year (2015-16), it is proposed to develop three benches in
Marble (Khanda) mine. The work will be carried out between the sections, X-X' & Y-Y'
at 336, 317, 311 and 305 mRL benches shown on Plate No. 5. No mineral stack yard is
required. Plantation will also be done as shown on plate no.-5.The details of total waste
rock handling during this year are given in Table 7.2.
During the period of forth year (2016-17), it is proposed to develop two benches in
Marble (Khanda) mine. The work will be carried out between the sections, X-X' & Y-Y'
at 311 and 305 mRL benches as shown on Plate No. 5. No mineral stack yard is required.
Plantation will also be done as shown on plate no.-5.The details of waste rock generation
are given in Table 7.3.
In fifth year (2017-18), it is proposed to develop two benches in Marble (Khanda) mine.
The work will be carried out along the sections, X-X' & Y-Y' at 305 & 299 mRL benches
as shown on Plate No. 5. No mineral stack yard is required. Plantation will also be done
as shown on plate no.-5.The details of waste rock generation during this year are given in
Table 7.4.
Table 7.1
Details showing estimation of bench-wise production of minerals during 1st Year of mine
planning.
Bench mRL Volume ROM (in tonne) O.B. (m3)
20
280 mRL to 275 mRL
36200
97740
Nil 275 mRL to 269 mRL
269 mRL to 263 mRL
ROM = 97,740 tonne
Recovery of Marble (95%) = 92,853 tonne
Overburden waste = Nil
Table 7.2
Details showing estimation of bench-wise production of minerals during 2nd Year of mine
planning.
Bench mRL Volume ROM (in tonne) O.B. (m3)
269 mRL to 263 mRL 36600 98,820 Nil
263 mRL to 257 mRL
ROM = 98,820 tonne
Recovery of Marble (95%) = 93,879 tonne
Overburden waste = Nil
Table 7.3
Details, showing estimation of bench-wise production of minerals and generation of
overburden waste during 3rd Year of mine planning.
Bench mRL Volume ROM (in tonne) O.B. (m3)
257 mRL to 251 mRL 37100 100170 Nil
251 mRL to 245 mRL
ROM = 1,00,170 tonne
Recovery of Marble (95%) = 95,162 tonne
Overburden waste = Nil
Table 7.4
Details, showing estimation of bench-wise production of minerals and generation of
overburden waste during 4th Year of mine planning.
Bench mRL Volume ROM (in tonne) O.B. (m3)
251 mRL to 245 mRL 35800 96660 Nil
245 mRL to 239 mRL
ROM = 96,660 tonne
Recovery of Marble (95%) = 91,827 tonne
21
Overburden waste = Nil
Table 7.7 – Year-wise production of Marble
Year Marble (Khanda)
1st Year (2014-15) 92,853
2nd Year (2015-16) 93,879
3rd Year (2016-17) 95,162
4th Year (2017-18) 91,827
Recovery of Marble is 95% of total reserve.
a) Mineable Reserve and anticipated life of the Mine: -
For estimation of mineable reserve the following parameters have been taken into
consideration:
i) Statutory barriers of 7.5m are not mineable.
b) Life of mine
We are considered average production of 90,000.0 MT of Marble (Khanda) per
annum from the mine.
Life of mine = Total mineable reserve/ Av. Annual Production
= 8, 73, 639/ 90,000
= 10 years
c) Proposed Method of Mining: -
It is a working lease. The mining is being carried out by open cast semi
mechanized method of mining. The bench height will be kept 6 m and width of the
benches will also not be less than the height of the bench. Statutory barrier of 7.5 m will
not be left and the required permission from the chief inspector of mines under rule 111 of
MMR 1961 will be taken.
It is further proposed that for mineral transportation from the mines, a haul road in
consultation with the adjoining lease holders will be developed which will be used by all
the lease holders gives consent to construct, run & maintain the haul road to have safe &
deeper working for optimum production.
The Mining of marble (Khanda) requires the drilling in the marble, charging the
drill holes with explosive and then blasting of the holes. The blasted material will be
22
loaded into the dumpers after proper sizing with the help of hammers and chisels. The
loaded material will be fed to the end users.
d) Conceptual Mining plan
The conceptual Mining Plan has been discussed up to anticipated life of the mine.
e) Ultimate Pit Limits
Presently, the existing pit is covering an area of 6950 m2, as shown in surface plan
(Plate 4). For the period of next four years, the mine planning has been given for this Pit.
In the proposed mine planning, the limits of Pit will be 100m × 100m (average) × 32 m at
the end of fifth year (refer Plate No. 6). So it will occupy an area of about 10,000 m2. The
ultimate pit limit will be at 260 mRL.
f) BLASTING: -
The Board blasting parameters will be as under: -
1. Spacing : 1.20 m
2. Burden : 0.8497 m
3. Depth of hole : 1.6 m. (In two stages)
4. Tonnage of each hole : 4.77 m
5. Charge per hole ANFO : 0.40 Kg
6. No. of Cartridge : 1
7. No. of hole per round : 20
8. No. of round per day : 2 to 3
9. No. of row : 1
10. Wt. Of Cartridge : 125 gm
11. Powder Factor : 6.05tonnes/Kg
TYPE OF EXPLOSIVE TO BE USED
1. ANFO (AN94%, FO 6%)
2. Slurry Explosive
3. Detonating Fuse
4. Ordinary Detonator /Electric detonator
5. Safety Fuse
STORAGE OF EXPLOSIVES
As mining Operation is on a limited scale, therefore, requirement of
explosive will be very low. No explosive will be stored at the mine site. Explosive
23
required for blasting will be transported from nearby magazine in an approved
explosive van and the residue explosive after blasting will be returned to the same
magazine. There will not be any infrastructure and mining operation in 50mtr
radius of magazine. Suitable provision of fencing, guard huts etc will be done as
per Indian Explosive Act. Blasting operation will be done by blaster / mines
manager appointed by the lessee.
SAFETY PRECAUTIONS: -
1. The position of every deep- hole to be drilled will be distinctly
marked by the foreman so as to be readily seen by the drillers.
2. (a) No drilling will be commenced in an area, where shots have
been fired, until the blaster has made thorough examination at all
places, including remaining butts of the old deep- holes, for
unexploded charges that the drill may strike.
(b) No drill or bore rod or pick will be inserted in the butts of old
deep- holes, even if the examination under clause (a) has failed to
reveal the presence of explosives.
3. (a) Drilling and charging of deep- holes will be carried out in the
same area at the same time.
(b) Drilling operations will not be carried on simultaneously on two
benches, at places directly one above the other.
4. Shots shall not be fired except during hours of day – light.
5. Shotfiring shall be carried out during the rest interval.
6. Before a shot is charged, stemmed or fired, it is ensured that all the
persons have taken proper shelter & also take suitable steps to
prevent any person approaching the shot.
7. Siren will be blown over the entire area falling within a radius of
500m from the place of firing.
8. Two persons will be posted, one in either direction at the two
extreme points of the road lying within the danger zone.
g) MINE DRAINAGE
The mining lease area is plain and country rock is hard, the runoff water
will be low and percolation of water will be high. All the surface water shall be
flowing towards south- western direction and join to a nalla.
24
Mining is proposed above the water table, so there will be no effect on
ground water table. The general ground water table in the area varies from 60- 65
m below the surface level of 333 mRL.
Therefore, ground water table will not be touched during first four years of
mining. Rain water may get accumulated during rainy season. Pumping shall be
done for collected water during rainy season.
h) Surface Plan & Section, etc. (Plate No.-3)
7.2 Waste rock management: -
There is no generation of waste, hence no waste rock management required.
7.3 Reclamation and Rehabilitation: -
There is no overburden material or waste generated during proposed mining so in
absence of it there will be no reclamation of the pit developed. However, for
rehabilitation, this pit will be develop as a water reservoir which will helping recharging
the ground water table of the surrounding area.(Plate No.- 6 & 7).
h) Extent of the area covered and number of saplings to be planted: -
Presently, some local small bushes are found near the mining lease area. During
the period of next four years, about 10 trees /year will be planted. By this, about 0.12 hect
area will be covered under plantation during the next four years. Local species like
Babool, Neem & Kikar will be planted to improve the environment.
CHAPTER- 8
Year wise annual Programme of Mining for next 4 Years
Year Marble (Khanda)
2nd Year (2014-15) 92,853
3rd Year (2015-16) 93,879
4th Year (2016-17) 95,162
5th Year (2017-18) 91,827
25
CHAPTER- 9
DETAILS OF EMPLOYMENT
Requirement of Technical, other staff and man power are as follows:
S.No. Designation Present Additional Qualification
1 Mining Engineer (Part time) 1 - B.E. in Mining
2 Mines Manager 1 - II class Mines
Manager’s Certificate
3 Mining Mate 1 1 Mining mate
4 Geologist (Part time) - 1 M.Sc. (Geology)
5 Surveyor (Part time) - 1 Mine surveyor’s
Certificate
6 Time keeper cum Store keeper 1 1 Secondary
7 HEMM Operators 2 4 Certificate holder
8 Laborers 5 15
It is proposed to employ labors on Contract basis.
CHAPTER – 10
MEASURES TAKEN AND TO BE TAKEN FOR LAND RESTORATION ,
RECLAMATION AND PLANTATION IN / OR NEARBY LEASE ARE A
As the area has not been exhausted completely, hence no restoration and reclamation of
land carried out. Lessee planted 10 trees every year but could not survive due to scarcity
of water.
PROGRAMME FOR PLANTATION
The area is mostly rocky with very poor density of vegetation. Plantation will be
carried out in the nearby village in consultation with Gram Panchayat. The total lease area
of 1.00 hect will be degraded due to mining which will be converted into water reservoir
at the end of life of mine in absence of non availability of backfill material.
26
Schedule of plantation for the next four years: -
S. No. Year of Plantation
Proposed Plantation
Assumed survival (80%)
Replenishment of Casualties
Total
1 I Yr. 10 8 - 8 2 II Yr. 10+2 10 2 10 3 III Yr. 10+2 10 2 10 4 IV Yr. 10+2 10 2 10
Place of proposed plantation: -
The plantation shall be done in the near village Baldevgarh in consultation with
Gram Panchayat.
CHAPTER – 11
MEASURES TAKEN AND TO BE TAKEN FOR PROTECTION OF
ENVIRONMENT IN AND AROUND MINING LEASE AREA
Measures have been taken for the protection of environment in and around mining
lease area.
To protect the environment in and around the mining lease area, in the last 10
years the lessee has reportedly planted 10 saplings per year but due to bad climatic
conditions, non availability of top soil and water, the saplings could not survived. The
lessee has also planted some trees near by the approach road but in absence of proper
care, the same could not be survived. However, the proposed plantation for the next four
years it is intended to provide tree guards for each saplings and regular watering.
PROTECTION OF ENVIRONMENT
27
Existing Land Use Pattern
Marble is mostly occupying the lease area. There is no agriculture land in the lease area.
The mining has been carried out in the govt. waste land. The existing land use pattern is
given in the format.
S. No. Particulars of Area Area in m2
1 Pits & Quarry 6950
2 Dumps of ores, waste and O.B. Nil
3 Infrastructure inclusive of
Office, workshop and plants Nil
4 Road Nil
5. Virgin Area 3050
Total Area
(i) Water Regime
There is no river, nalah, pond etc. within the lease area. It is a plain area.
Reportedly, the water table is about 60- 65 m below the general surface. The quality of
water of a well outside the lease area at about 1 km from the mine site is reportedly
normal and potable.
(ii) Flora & Fauna
Scanty local bushes are there in the area, which are grown during rainy season.
There is no other fauna observed and reported in and around the lease area.
(iii) Forest
Few bushes can be seen in the area. Moreover there is no demarcated/protected
forest close to the Lease area. The protected wildlife animal in & around Lease area is
also not present.
(iv) Climatic Condition
The area is characterized by semi arid type with an average annual rainfall of
about 565 mm. which is mainly received during July to September.
The minimum temp recorded as 1.4º during winter whereas maximum temp
recorded during summer is 47º C. General Wind direction is south west to north east.
10000 m2
28
(v) Public buildings, places and monuments
No such buildings, places and monuments exist in or nearby the area.
(vi) Quality of Air
The air quality is free from any pollutant.
Impact of mining
The sources of air pollution in the area due to mining will be mainly from dust
generation by plying of trucks and dumpers on unpaved mine road. The dust is also
generated during drilling whereas quality of air is affected due to emission of gases from
different machineries and Smoke generated during blasting which is momentarily, &
occasionally.
Remedies
Water spray is being carried out occasionally over the excavated material as well
as on the haul road to minimize the dust during loading & transportation.
ENVIRONMENT
Impact of mining on the Environment: The common adverse effect of mining on
environment is as under:
(A) Land Environment
(i) Land Scape
The landscape of this lease area has been changed by current mining
operations. It will further increase due to proposed mining in the area. The total
area of the lease which will be disturbed at the end of the proposed four years of
mining will be around 1.00 hect upto a depth of 299 mRL.
(ii) Aesthetic Environment
At present, the area is rugged and plain. It has no aesthetic beauty. Due to
mining of Marble, a little aesthetic environment may change for the area and the
surroundings.
(iii) Soil and Land Use Pattern
There is no soil cover in the area. By mining of Marble a little land use is changed
due to pit excavation.
(iv) Agriculture
29
The mining is being done on Govt. waste land and will be continued in
Govt. waste land only so there will be no impact on agriculture.
(v) Forest
The mining lease area does not fall in any type of forest land. No forest
within core and buffer zone falls, so there is no impact takes place on the forest.
(vi) Vegetation
There is no vegetation in the mining lease area. Some seasonal bushes are
there which has no importance, so no effect is taking place by mining activities on
vegetation.
(vii) Public Building, Places and Monuments
No public building, places of monuments etc. are there in or nearby the
lease area, so there will be no effect by mining activities on any public building,
places and monuments.
CHAPTER – 12
MEASURE TAKEN AND TO BE TAKEN FOR DUMPING OVERBURDE N,
STACKING OF TOP SOIL AND UTILISATION OF TOP SOIL
Measures Taken for, Stacking of Top Soil and Utilization of Top Soil: -
There is no top soil to be stacked separately and utilized. So it does not require any
measures to be taken for stacking and utilization.
DISPOSAL OF WASTE
Nature of Waste: -
There is no waste generated due to mining of Marble (Khanda) so question does not arise
for its disposal.
30
CHAPTER – 13
MEASURE TAKEN AND TO BE TAKEN FOR THE CONTROL OF WA TER,
NOISE AND AIR POLLUTION
Surface Water: - There is no source of surface water in and around the mining lease area.
So no measure is required to control it.
Ground Water: - The proposed mine working is up to 299 mRL which is far above the
general ground water table, hence no measures is required to control it.
Water Quality
No impact will take place due to mining activities on water quality, as no toxic or
polluted water will be discharged. The pit depth will also not go below water table.
Noise Pollution
In the proposed mining the use of machines like excavator and dumper will
produce some noise. To control these noises the machines will be regularly maintained
properly by greasing, oiling etc. as well as providing protective equipments to all the mine
workers.
(i) Noise
31
The source of the noise in mining particularly in this area can be due to
(1) Mobile plant (Drilling, running of compressors etc.)
(2) External Transport Plant related with supply of material running of trucks and
dumpers etc.
(3) Explosive detonation, Sound waves etc.
No sound pollution will be caused by above source, as the sound generated will be
kept within permissible limit. The blasting will not be done at high scale and hence
practically no ground vibration will take place. The noise level during blasting will be
high but it will be for momentarily. Scientific blasting will be adopted hence ground
vibration will not take place.
Air Pollution
(i) Dust
The impact on the air due to mining activities can take place by following
activities
Formation of Dust: following reason makes Formation of dust:
(a) Drilling and blasting operation,
(b) Running of external transport machinery like dumpers, trucks in the mining area,
blasting operation. Due to small scale mining impact will be very low in the form of small
amount of air borne dust.
(ii) Climatic Condition
Climatic condition of the area will not change by mining activities, as the mining
activities will be of a very limited nature, so there will be no impact of mining on climatic
condition.
32
CHAPTER – 14
CONTRIBUTION REGARDING THE SOCIAL DEVELOPMENT OF TH E
NEARBY RESIDENTS
(A) Social Development
(i) Social and Demographic Profile
In the proposed mining there will be direct employment of 25 persons so
considering a family of 4 members for each employee the social development will be for
100 persons. Other than this indirectly about 50 % will also be benefited by proposed
mining so it is proposed that the lessee should spend 1% of profit for the development of
the area by donating the amount for development on education, cultural and other social
activities of the community near by the mine site.
(ii) Occupational Health and Safety
Due to proposed mining during drilling and transportation there may be dust
generation so to prevent the occupational disease, the measure as proposed in drilling
operation in will be taken, which, will prevent inhalation of the dust by the workers. The
33
workers will be periodically medically examined as required under Rule 29(b) of Mines
Rule. If any worker found to have any occupational disease he will be immediately
provided with proper medical care as per provision of Mines Rule.
Safety
To prevent the worker getting any injury during work following measure will be taken:
(i) The workers will be trained by periodical vocational training programs. They will be
given proper training in particular work area/ field.
(ii) The workers will be provided proper safety wearing and equipments such as hand
gloves, safety boots, helmets, and lifeline jackets etc.
(iii) Proper & systematic benches will be formed. Apart from this, all safety precaution
will be taken as per Mines Act, Rules, Regulation and Byelaws made there under.
(iii) Human Settlement
There is no human settlement within and around 500 m. periphery of the lease area.
The workers will be hired from the nearby village and only day shift working has been
proposed so, it will raise the living standards of the nearby inhabitants.
(iv) Recreational Facility
Presently there is no recreational facility available. The lessee is proposing to have
in-house recreational facilities like carom, ludo, chess and video games.
Post Plantation Care:
i) Protection from Grazing
It is proposed to keep 1 casual labor to water the plants, there protection from
grazing, erecting fencing etc. regularly.
(ii) Watering during Dry Spell
It is proposed to plant 10 trees/ year of Babool, Neem & Khakra, though these
trees will require very less water but, in the first year from April to July, the watering will
be done by the daily casual worker and October to March thrice in a week by deploying
water tanker. Thereafter, each year watering will be done alternate day & during dry spell
once in daily.
(iii) Manuring
The local manuring will be done once in forth night after plantation work is taken up.
34
(iv) Protective measures will be taken on pre and post plantation period to control pest
like white ant etc. After a few months liquid pesticide mixed with 100 times water will be
spread over the planted saplings.
(v) Replenishment of Casualties
The loss of each year will be counted and in subsequent plantation casualties will be again
planted at same place. This way in the end of 4th year 40 healthy trees will remain be there
in the area.
CHAPTER – 15
DETAIL OF HEALTH CHECKUP AND INSURANCE OF ALL THE
EMPLOYED PERSONS (FOR EXISTING LEASE)
Initial and periodical Medical examination will be conducted annually for every person
employed in the mines 25% of the total employee get examined medically every year, so
that all the person employed in the mine get examined within four years as per Mines
rules-1955.
Any Other Information: -
Mr. Manish Kumar and Miss Sabista, Geologists assisted in preparation of Plans
& Sections, Assessment of Reserves, Mine Development Plan, Environment Plan &
Conceptual Plan etc.
35
Place : Jaipur (Arun Kumar Yadav)
Date : RQP/AJM/242/2003/A
Validity:-21St May 2023
Recommended