World Leader in Control & Measurement

www.hynux.com

11/12November / December | 2013

HANYOUNG LETTER

New ProductsSlim-Type Thyristor Power Regulator

Small Cam Switch

LED Pilot Lamp & Push Button Switch

Multi-Loop Controller

Hanyoung NewsHanyoung Participated in 2013 Korea Machinery Fair

Website Renewal Opened

76,800 bps communication speed

0.05 sec. sampling period (4 channels)

4-channel relay / voltage / current output

8 Event outputs

Maximum 31 parallel connections

Stop / Monitor / Operation mode

SV / minute rate of change adjustment

Feature

ComingsoonComingsoon

Suffix CodeModel Code Description

ML- ☐ ☐ ☐ Multi loop controller

Channel2 2 Channel

4 4 Channel

Output type

M Relay

S S.S.R (12 V d.c)

C S.C.R (4 - 20 ㎃ d.c)

Model Code Description

ML- ☐ ☐ ☐ Multi loop controller

Type E Event output

Channel 8 8 Channels

SpecificationModel ML-D4M ML-D4S ML-D4C

Input

Number of input 4 Nos. (channel-to-channel isolation)

Input type

•Thermocouple : K, J, E, T, R, B, S, L, N, U, W, PLⅡ •DC Voltage : 1 - 5 V d.c, 0 - 10 V d.c, 0 - 100 ㎷ d.c

•RTD : KPt100 Ω (K.S), Pt100 Ω (IEC / K.S), 3-Wire (wire resistance less than 10 Ω / a line)

•Direct circuit : after input type is set to direct circuit 1-5 V d.c., input terminal is stick at positive terminal to 250Ω resistence

Operation with Burn-out 1) Thermocouple : Up scale 2) RTD : Up scale 3) DC Voltage : Down scale 4) DC Current : Down scale

Influence of signal source resistance 0.2 uV / Ω (thermocouple input)

Influence of source resistance 0.02 % / Ω (RTD) 10 Ω max. per line

Intervals 0.05s / Channel

Input filter 0(off) - 120s

PV bias EUS (-100 ~ +100 %)

Performance

Input degree ±0.3 % of F.S

Effect of ambient temperature ±3 uV / ℃ or ±0.03 % of F.S / ℃ (whichever is greater)

Effect of power fluctuation ±3 uV / 10 V or ±0.03 % of F.S / 10 V (whichever is greater)

Control output

Type Relay output Voltage pulse output Current output

Rating •Relay output 250 V a.c 3 A, 30 V d.c 3 A •Voltage pulse output 0/15 V d.c (at minimum load resistance : 600 Ω) •Current output 4 - 20 ㎃ d.c (at maximum load resistance : 600 Ω)

Communication

Communication method RS-485 (two-wire, half duplex)

Communication speed 9600 bps, 19200 bps, 38400 bps, 76800 bps

Communication protocol PC-Link, PC-Link with SUM, MODBUS-RTU / ASCII

Bit length •Start bit : 1, 2 •Data bit : 7, 8 •Parity bit : none, odd, even •Stop bit : 1, 2

Maximun connection in parallel 31 units

Event output(ML-E)

Number of output 8 Nos.

Output operation ON / OFF

Output type Relay output 250 V a.c 3 A, 30 V d.c 3 A

Event type• Deviation high • Deviation low limit • Deviation high/low • variation in the range • PV high limit • PV low limit

• SV high limit • SV lower • Loop break (LBA) • Operation (RUN) • Stop monitor (Ready) • Fail

Multi-Loop ControllerML series

NE

W P

RO

DU

CT

Slim-TypeThyristor Power Regulator

Ultra Slim type (110 ㎜)

Semi permanent life expectancy due to the best radiant heat design and installation of various protection circuit

Improved reliability by separating controllerpower from load power (apply a wide range of power supply circuit)

Various protection functions (Disconnection of heater, Imbalance of load, Overheated heat sink, Overcurrent etc.)

TPR-3SL series

Suffix CodeModel Code Description

TPR - 3SL ☐ ☐ ☐ Slim type 3 phases thyristor power regulator

Input Control Voltage Contact

040 40 A

055 55 A

070 70 A

Rated load currentL 100 - 240 V a.c. (Low voltage)

H 380 - 440 V a.c. (High voltage)

Option- Inner part of Fuse is installed

N No Fuse

Feature

Specification

ModelLow TPR-3SL040L TPR-3SL055L TPR-3SL070L

High TPR-3SL040H TPR-3SL055H TPR-3SL070H

Power supply voltage100 - 240 V a.c. (Low)

380 - 440 V a.c. (High)

Circuit input power 100 - 240 V a.c.

Power frequency 50 ㎐/60 ㎐ (Dual usage)

Rated current 40 A 55 A 70 A

Applying load Load resistance

Controlinput

Currebt input 4 - 20 ㎃ d.c (Impedence : 100 Ω)

Voltage input 1 - 5 V d.c.

Contact input ON/OFF

External V.R External volume (10 ㏀)

Control method Phase control, Fixed cycle control, Variable cycle control, ON/OFF control

Movement type SOFT START, SOFT UP/DOWN

Output voltage More than 98 % of the power supply voltage ( In case of maximum current input )

Cooling method Natural cooling ( 40 A , 55 A ), Forced cooling ( 70 A )

Display method Display by LED

Insulating resistance Min 100 ㏁ ( Base on 500 V d.c mega )

Output cotrol range 0 ~ 100 %

Dielectric strength 3,000 V a.c 50/60 ㎐ for 1 min

Line noise Noise by noise simulator (2,500 V)

Storage temperature -25 ℃ ~ 70 ℃

Ambient temperature 0 ~ 40 ℃ (with no condenssation)

Ambient humidity 30 ~ 85 % RH

Weight 4044 g 4324 g

※ For circuit input power, please connect 100 - 240 V a.c separately.

ComingsoonComingsoon

NE

W P

RO

DU

CT

Suffix Code

Specification

█ LED Pilot Lamp

█ LED Pilot Lamp

█ Push button switch (Contact Part)

█ Push Button Switch (Actuator Part)

█ Push Button Switch (Contact Part)

█ Push Button Switch

Model Code Description

CR- ☐ ☐ ☐ ☐ CR series LED Pilot lamp

Installing Dimension

252 Ø25 Pilot Lamp

302 Ø30 Pilot Lamp

Power Supply Voltage (Exclusive Unit of LED Light Source)

A 110 V a.c. LED Light Source (Way of dropping of Condenser Voltage)Example) CR-☐☐☐F☐

B 220 V a.c.

C 380 V a.c.

D 24 V d.c. LED Light Source (Way of dropping of resistance voltage)E 12 V d.c.

Light Source FExclusive unit of LED Light Source

※Only power voltage A, B, C, D, E

Lamp Cap Color R Red(R), Green,(G), Yellow,(Y), Blue,(A), White(W)

Model Code Description

CR- ☐ ☐ ☐ ☐ Push Button Switch of CR Series (LED Dimmer)

Installing Dimension

254 25 push button switch (1a1b contact only)

304 30 push button switch (1a1b contact only)

Power Supply Voltage (Exclusive Unit of LED Light Source)

A 110 V a.c. LED Light Source(Way of dropping Condenser Voltage)Example) CR-☐4☐F☐

B 220 V a.c.

C 380 V a.c.

D 24 V d.c. / a.c. LED Light Source (way of dropping resistance voltage)E 12 V d.c. / a.c.

Light Source FExclusive unit of LED Light Source

※Only power voltage A, B, C, D, E

Lamp Cap Color R Red(R), Green,(G), Yellow,(Y), Blue,(A), White(W)

Rated VoltageAlternate Current Direct Current

110 V a.c. 220 V a.c. 380 V a.c. 24 V d.c. 12 V d.c.

Current Consumption 16.6 ㎃ 13 ㎃ 6.55 ㎃ 15 ㎃ 15 ㎃

Life Expectancy of Light Source

100,000 h

Tightening Torque of Locking Ring

1.96 N·m

Tightening Torque of Terminal

0.8 N·m (M3.5 x 7)

Thickness of Installation Panel 1 ~ 6 ㎜ (Without Accessories)

Contact Rating 5 A 250 V a.c.

Contact Resistance Max 50 ㏁

Contact Material AgCdO

Contact Case Material Contact Cover : P.C., Contact Body : ABS

Contact Composition 1a1b

Contact Operation Slow-Action

Frequency of Allowable operation

Mechanical Maximum 30 times per 1 minute

Electrical Maximum 30 times per 1 minute

Insulation Resistence. Min 100 ㏁

Withstand Voltage 1,500 V a.c. / 60 ㎐, 1 min

Vibration Durability 10 ~ 55 ㎐(Double amplitude 3㎜)

ImpactDurability Over 500 ㎨

False Operation Over 100 ㎨

Life Expectancy

Mechanical Over One million Times

Electrical Over 100000 Times

Ambient Temperature -25 ~ 40 ℃

Ambient Humidity 45 ~ 85 % R.H

Storage Temperature -40 ~ +70 ℃

Impact (Durability) 300 ㎨. Pulse Period 11 ㎳

Vibration (Durability) 100 ㎨ 10 ㎐…55 ㎐ Double amplitude 1.5 ㎜ (within 1 ㎳)

Rated VoltageAlternate Current Direct Current

110 V a.c. 220 V a.c. 380 V a.c. 24 V d.c. 12 V d.c.

Current Consumption 16.6 ㎃ 13 ㎃ 6.55 ㎃ 15 ㎃ 15 ㎃

Life Expectancy of Light Source

100,000 h

Tightening Torque of Locking Ring

1.96 N·m

Tightening Torque of Terminal

0.8 N·m (M3.5 x 7)

Contact Materials ABS (Mounting Nut and body)

Feature

LED Pilot Lamp & Push Button Switch

CR series

Ø25 Ø30 Series

Formation of Contact Part: 1a1b one body type.

Long life expecntacy due to effect of LED Light Source

Reduce the weight of the product

NE

W P

RO

DU

CT Comingsoon

Comingsoon

Small Cam SwitchSQ4 series

Suffix CodeModel Code Description

SQ4- ☐ ☐ ☐- ☐ ☐ ☐ ☐ SQ4 Series Cam Switch

Installation F Four holes of panel mounting

Nameplate Frame S Square of Nameplate Frame

HandleH Linear Handle (For General Industry)

R Chrysanthemum type of Handle (Voltmeter and Ammeter Switch)

Positions selection

2 2 Position

3 3 Position

4 4 Position

5 5 Position

6 6 Position

7 7 Position

Number of contact unit

1 1 row

2 2 row

3 3 row

4 4 row

5 5 row

6 6 row

Serial Number 0 1 01 ~ 99

Feature

SpecificationRated Insulation voltage 690 V a.c.

Dielectric strength 2500 V a.c.

Rated Electro Current (Ith) 16 A

Rated Service Voltage (Ie) 16 A

Rated Service Current (Ue) 480 V a.c.

Mechanical Life Expectancy 300,000 Times

Electrical Life Expectancy AC : 200,000 Times, DC : 100,000 Times

Ambient Temperature -25 ~ 55 ℃

Ambient Humidity Max 90 % RH

Altitude Max 2000 m

Protective Structure IP65

Pollution level 3

Component Materials

BodyNY66 GF15 % Level

of Resistence to flame

Cam ACETAL

Contact AgNi

Terminal Brass

Bolt Iron (Galvanizing)

Spring Stainless (STS)

Handle Level of PC Resistence to flame

2 Types of operation handle (H type, R type)

Ammeter Switch (A.S), Voltmeter Switch (V.S.)

Various Circuit of Small Cam Switch

Structure of Contact: Maximum 7 positions and 6 rows

IP65 structure

NE

W P

RO

DU

CT

ComingsoonComingsoon

Hanyoung Nux Participated in 2013 Korea Machinery Fair.

Field Sketch of Korea Machinery Fair Korea Machinery Fair / KINTEX October 16 - 19, 2013We participated in Korea’s largest exhibition, 2013 Korea Machinery Fair, which was held from October 16th to October 19th.

This Korea Machinery Fair was the Korea’s largest exhibition which was combined by five vital capital exhibitions, Tool Tech

Korea, Welding Korea, Korea Metal Week, Korea Automatic Industrial Exhibition Etc. In this Machinery Fair, Hanyoung Nux

introduces new products including Digital Temperature Controller and HMI, Graphic Recorder, Solid State Relay, Multi Loop

Controller, Proximity Sensor, and Photo Sensor Etc.

Especially, HMI (Human Machine Interface) TG Series which was introduced in this exhibition is mostly attracted by audience. HMI, various structure of 5, 7, 10, 12, 15 inch, is expected to be the most issued product.

Moreover, DPS Series which is DIN Rail type of Power Supply (SMPS) is also highly attracted by audience.

TG series

DPS series

HA

NYO

UN

G N

EW

S

Hanyoung Nux’s Website Renewal Opened

www.hynux.comHanyoung Nux’s website is renewal opened for

providing various and convenient information

about products to customers.

Since product’s images are placed in main

page of category, it makes customers to find

out the products easily so that it leads to

optical convenience. Also, mobile website is

opened for convenience of Smartphone users

and it makes them to get information easily

wherever they are.

HA

NYO

UN

G N

EW

S