Est. 1994
1600 East 78th St. Richfield, MN 55423(612)866-1200 (800)466-7946 US, Canada, Mexico
www.ecosmarte.comwww.glasspackfilter.com
Preventing Biofilm and Bacteria in Dental Operatory TubingBy: Greg Steiner
ECOsmarte’s natural oxygen and ionic copper system has prevented the formation of biofilms andbacteria in dental operating tubage successfullysince 2006.
“The ECOsmarte system can be configured with allforms of conventional water treatment at the point ofentry, with or without a conventional water softenerand regardless of whether the source water is municipally chlorinated or a conventional well.
Both of ECOsmarte’s Minneapolis based dentaloffices have approximately 400ppm calcium, .3ppmiron and use a 2 cube GAC filter with a one inchvalve. One site uses a 48,000 grain softener (Brite Smiles) and the other uses the ECOsmarteelectronics for bicarbonate calcium control (SteinerDental).
“The potential for dangerous biofilmmicrobes has been noted by federal regulatory agencies including OSHA andis noted periodically in industry tradeperiodicals.”
“ECOsmarte furnishes a Millipore bacteria test kitalong with a simple five drop Lamotte EC test kit,with testing assigned to the employee who sterilizesthe instruments. The concept is simple. We simplypretend the dental office is an Apollo Lunar Modulewhen NASA used ionization on three week missionsto the moon.” They used the ionization because itwas more effective on single cell microbes than chlo-rine, had a safe and stable residual for humans andwas the best technology to combat moon microbes.
The ECOsmarte Dental System treats full facilitywater at 1500 available gallons per day, requiresannual purchase of test kits for $75 and semi-annualanode cleaning furnished by the local dealer foraround $156.
Properly installed, the ECOsmarte electronics prevent the formulation of bacteria in the point-of-entry filters and allow a three year filter life at aninstalled cost of around $1000.
Annually the ECOsmarte purification system cantreat easily 250,000 gallons for $500. At 1/5 of onepenny per gallon (.002) this is a small price to pay forthe safety of the customers and employees.
Copyright 2009 ECOsmarte Pools, Spas and Water, Inc.
Est. 1994
1600 East 78th St. Richfield, MN 55423(612)866-1200 (800)466-7946 US, Canada, Mexicowww.ecosmarte.comwww.glasspackfilter.com
MECHANICAL & PLUMBING
Operating Press. Max. 150 PSIG
Operation Temp. Max. 120˚ F
Tank listing and structural integrity
requirements only.
OXYGEN ELECTRODES
Proprietary composite material
IONIZATION ELECTRODES
100% Pure Copper
ELECTRICAL
Input Voltage: 110 to 267 Volts, Specify
Output Voltage: 100 VA Class UL CSA
Compliance Power Supply
GPM: Each Unit 1 GPM to 30 GPM
Municipal and Well Water Systems AvailableFull Facility Approach
TECHNICAL SPECIFICATIONS
©Copyright 2003 - 2007 ECOsmarte Planet Friendly, Inc. 1600 East 78th Street, Minneapolis, MN 55423 1
POINT-OF-ENTRYWATER TREATMENT
ON HIGH
ECOsmarte® Point-of-Entry110VPower Settings:HIGH: Low TDS Waters
(below 500ppm)LOW: Medium to High TDS Waters
(above 500 ppm)
½ to 1½ amp. fuse
(Connect Relay Valve To Control Box Connector)
Thicker wire to chamber, thinner to valve. Both of the thicker wires connect to copper bars.
2850Control Head
Rinse at 3000gallons
To Home
LIGHT COMMERCIAL w/ 1” INSTALL CONFIGURATION
Lights will circle on control box, indicating power to the electrodes, when faucet is opened.
Jumper Wire
DUAL ELECTRODES
Titanium OxidationNatural Oxygen
Copper Ionization
An Alternative Science to
Water Softening and
Reverse Osmosis...
EPA EST#68770-CA-001
From City Line
HydroxiteTMMeasured Mineral Media(optional - based on city water source)
Granular Activated Carbon(to be installed last, pre-measured chemical removal media)
Freeboard(30% of Tank)
(SET TO RINSEON PIN 6)
1-800-466-7946
Sterile Pea Rock
Larger stones toward bottom.
Biofilm control in the dental operatorytubing is confirmed by a simple five drop reagent test for copper ppm.
ECOsmarte and Glass Pack Filter are registered US Trademarks of ECOsmarte Planet Friendly, Inc. in over 26 countries
The ECOsmarte system hasbeen tested and Certified byWQA according toNSF/ANSI 61, Section 8