thPrice Schedule - Effective 19 April, 2011
Price SchedulethEffective 19 April, 2011
Low Voltage Components
Power Capacitor
ACE 2 & ACE - Moulded Case Circuit Breakers
9
17
19
26
33
33
34
26
26
24-25
23
22
21
20
, Integrated Dual Colour LED
36-37
38-40
41
44
46
49
Selector
42
Moulded Switches with Plastic Enclosure
16
72
71
71
70
69
68
67
66
65
64
63
62
61
60
59
58
58
57
55
53
3 Phase DOL Motor Starter & Submersible Pump Control Unit
Star Delta, Agro Starter Spares
DOL: Starter in Plastic Enclosure, Reversing
Star Delta Starter & Intelligent Auto Transformer
75
79
83
D Range Control Relay, 3 Pole Contactor & Overload Relay & 4 Pole Contactor
4 Pole & 2 Pole Contactor & Overload Relay
Price ListAir Circuit Brakers Control & Signalling Devices
General Terms & Conditions
n
n
POR - Price on request
Products have been classified as Stockable & Non Stockable
items. Non Stockable items has been marked as
Introducing
For prices please contact nearest branch office.
Circuit Breaker630A to 4000 A
• Frame-I: 630~2000A, 50/65kA
• Frame-II: 2000~4000A, 65/80kA
3 & 4 Pole
Ics=Icu=Icw (for 1sec)
Versions: Manual/Electrical; Fixed/Draw out
High Impulse Withstand 12kV
Fastest opening & closing ACB~ 30 & 40 ms respectively
Common clip-on type accessories – U/V,S/Trip & Closing coil
Easy conversion: MDO to EDO Breaker
Zone Selective Interlocking
Common Height & depth
Standardize Panel Cutout
Busbar Termination: Horizontal, Vertical or Mixed
Compliance to IEC 60947/IS13947-2 .
W Nmasteri630A to 4000A, 3 & 4 Pole
ProtectionsMultiple Release options
• Protection-O/L , S/C, Instant, E/Fault, E/Leakage, Voltage Unbalance & Reverse Power
• Measurement -Current, Voltage, Power, Energy & Power Factor
• Harmonics Filter - upto 31st order
• Communication: RS485 port Protocol : Modbus/Profibus
MicroPro 3.0
Overload protection
Short Circuit protection
MicroPro 3.1
Overload protection
Short Circuit protection
Earth Fault protection
MicroPro 4.1 / 5.1
Overload & Short Circuit protection
Instantaneous current protection
Neutral & Ground Fault Protection
Zone Selective Interlocking
LCD display and fault LED retention in case of power failure
Measure true RMS values of current (all three phase)
MicroPro 6.1
Overload & Short Circuit protection
Instantaneous current protection
Neutral & Ground Fault / Leakage Protection
Under / Over voltage and frequency protection
Phase sequence, Current /Voltage unbalance & Reverse Power Protection
Zone Selective Interlocking.
Measurement of V, I, P, Hz, kWh, kVArh, PF etc.
MicroPro 7.1
Overload & Short Circuit protection
Instantaneous current protection
Neutral & Ground Fault / Leakage Protection
Under / Over voltage and frequency protection
Phase sequence, Current /Voltage unbalance & Reverse Power Protection
Zone Selective Interlocking
Measurement of V, I, P, Hz, kWh, kVArh, PF & Harmonics
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
Intelligent Protection Release
• i•
COM option in W Nmaster with micropro 4.1, 5.1, 6.1 & 7.1Port: RS 485, Protocol: Modbus, Profibus* & Device net** available with micropro 6.1 & 7.1 only
Communication
List Price w.e.f. 10th April 2009 9List Price w.e.f. 19th April 2011 9
Fixed 3 Pole
630 AH06DCSMP4.1*(S)
800 AH08DCSMP4.1*(S)
800 AHA08N3P*MP4.1 (S)
1000 AH10DCSMP4.1*(S)
1250 AH12DCSMP4.1*(S)
1600 AH16DCSMP4.1*(S) POR POR
2000 AHA20N3P*MP4.1 (S)
2000 AH20DCSMP4.1*(S)
2500 AH25DCSMP4.1*(S)
3200 AH30DCSMP4.1*(S)
4000 AH40DCSMP4.1*(S)
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MF *EF
Fixed 4 Pole
630 AH06D4CSMP4.1*(S)800 AH08D4CSMP4.1*(S)
800 AHA08N4P*MP4.1 (S)
1000 AH10D4CSMP4.1*(S)
1250 AH12D4CSMP4.1*(S)1600 AH16D4CSMP4.1*(S) POR POR
2000 AHA20N4P*MP4.1 (S)
2000 AH20D4CSMP4.1*(S)
2500 AH25D4CSMP4.1*(S)3200 AH30D4CSMP4.1*(S)
4000 AH40D4CSMP4.1*(S)
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MF *EF
Air Circuit Breaker "D" Series(I) ACB with Intelligent Release MicroPro 4.1
Features :
• LSING Protection • True RMS Sensing • Zone Selectivity• LCD Display • Thermal Memory • Fault Indication• Current Measurement
"D" series breakers fitted with standard accessories, tabulated below, are included in the Prices mentioned in the subsequent tables.
LT Air Circuit Breaker fitted with Intelligent Release MicroPro 4.1
ACB "D" SERIESACB "D" SERIESACB "D" SERIESACB "D" SERIESACB "D" SERIES
- Microprocessor Release
- Auxiliary Switch 5a 5b i.e 5NO+5NC
- Main CTs for 3 Phase only
- Microprocessor Release
- Auxiliary Switch 5a 5b i.e. 5NO + 5NC
- Main CTs for 3 Phase only
- AC/DC Charging Motor
- Closing Coil
- Shunt Trip
- Anti-pumping Relay
- Micro Switches as required for electrical operation
- Microprocessor Release- Auxil iary Switch 7a 7b i.e. 7 NO +7 NC- Main CTs for 3 Phase only- Safety Shutter- 36 way Auxiliary Isolating contacts- AC/DC Charging Motor- Closing Coil- Shunt Trip- Anti-pumping Relay- Micro Switches as required for electrical
operation- Terminal Type-Horizontal upto
2500A & Vertical for 3200 / 4000A #
- Microprocessor Release
- Auxiliary Switch 7a 7b i.e. 7NO + 7NC
- Main CTs for 3 Phase only
- Safety Shutter
- 36 way Auxiliary Isolating contacts
- Termimal Type - Horizontal upto 2500A& Vertical for 3200 / 4000A #
Manual Fixed (MF) Electrical Drawout (EDO)Manual Drawout (MDO)Electrical Fixed (EF)
Drawout 3 Pole
630 AH06DCSMP4.1*(S) 111200 149500
800 AH08DCSMP4.1*(S) 115000 150500
800 AHA08N3P*MP4.1 (S) 120000 155500
1000 AH10DCSMP4.1*(S) 124500 158000
1250 AH12DCSMP4.1*(S) 150500 182500
1600 AH16DCSMP4.1*(S) 158500 193500
2000 AHA20N3P*MP4.1 (S) 186500 221500
2000 AH20DCSMP4.1*(S) POR POR
2500 AH25DCSMP4.1*(S) 217000 248000
3200 AH30DCSMP4.1*(S) 282000 314500
4000 AH40DCSMP4.1*(S) 366000 398000
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MDO *EDO
Drawout 4 Pole
630 AH06D4CSMP4.1*(S) 142000 181500
800 AH08D4CSMP4.1*(S) 146000 184000
800 AHA08N4P*MP4.1 (S) 151000 189000
1000 AH10D4CSMP4.1*(S) 155000 193000
1250 AH12D4CSMP4.1*(S) 185500 221500
1600 AH16D4CSMP4.1*(S) 203000 237000
2000 AHA20N4P*MP4.1 (S) 242100 277000
2000 AH20D4CSMP4.1*(S) POR POR
2500 AH25D4CSMP4.1*(S) 280500 312500
3200 AH30D4CSMP4.1*(S) 347000 377500
4000 AH40D4CSMP4.1*(S) 448500 479500
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MDO *EDO
Notes :1) In TP ACB if Earth Fault facility is required, add price of Neutral CTs from item no. 3 on page 12.2) If Under Voltage Release is required, add price of UVT Coil from item no. 7 on page 13.
3) While ordering an ACB, complete the catalogue reference by replacing '*' with ACB type: MF - Manual Fixed,EF-Electrical Fixed, MD- Manual Drawout, ED-Electrical Drawout
4) All configured ACBs are non stockable. For further details please contact nearest branch office.5) ACBs with higher breaking capacities are also available on request.6) Power supply module (PSM) is supplied along with MicroPro 4.1 release, as a standard.
For ACB communication through RS 485 Port, please refer i tem no. 55 on page 15.For ACB communication through RS 485 Port, please refer i tem no. 55 on page 15.For ACB communication through RS 485 Port, please refer i tem no. 55 on page 15.For ACB communication through RS 485 Port, please refer i tem no. 55 on page 15.For ACB communication through RS 485 Port, please refer i tem no. 55 on page 15.
800A ACB - 45 kA breaking capacity. 800A ACB - 50kA breaking capacity.# ACB with vertical terminals are available on request. N o n S t o c k a b l e i t e m
List Price w.e.f. 19th April 201110
Air Circuit Breaker "D" Series(II) ACB with Microprocessor Release
Fixed, 3 Pole Fixed, 4 Pole
630 AH-6D-4CS-MP- * 78500 117000
800 AH-8D-4CS-MP- * 82500 122500
800 AHA-08N4P*MP 87500 127500
1000 AH-10D-4CS-MP- * 90500 128000
1250 AH-12D-4CS-MP- * 120000 15600
1600 AH-16D-4CS-MP- * 124500 162000
2000 AHA-20N4P*MP 147500 188000
2000 AH-20D-4CS-MP- * POR POR
2500 AH-25D-4CS-MP- * 168000 205000
3200 AH-30D-4CS-MP- * 245500 283500
4000 AH-40D-4CS-MP- * 372500 429500
Drawout, 3 Pole Drawout, 4 Pole
- Microprocessor Release
- Auxiliary Switch 5a 5b i.e 5NO+5NC
- Main CTs for 3 Phase only
- Microprocessor Release
- Auxiliary Switch 5a 5b i.e. 5NO + 5NC
- Main CTs for 3 Phase only
- AC/DC Charging Motor
- Closing Coil
- Shunt Trip
- Anti-pumping Relay
- Micro Switches as required for electrical operation
- Microprocessor Release- Auxil iary Switch 7a 7b i.e. 7 NO +7 NC- Main CTs for 3 Phase only- Safety Shutter- 36 way Auxiliary Isolating contacts- AC/DC Charging Motor- Closing Coil- Shunt Trip- Anti-pumping Relay- Micro Switches as required for electrical
operation- Terminal Type-Horizontal upto
2500A & Vertical for 3200 / 4000A #
- Microprocessor Release
- Auxiliary Switch 7a 7b i.e. 7NO + 7NC
- Main CTs for 3 Phase only
- Safety Shutter
- 36 way Auxiliary Isolating contacts
- Termimal Type - Horizontal upto 2500A& Vertical for 3200 / 4000A #
LT Air Circuit Breaker fitted with Microprocessor Release type μμμμμIT-100 / μμμμμIT-G (Includes Rectifier Unit 220V AC / 24V DC type
ARO - 1B in standard supply)
630 AH-6D-4CS-MP- * 125000 164500
800 AH-8D-4CS-MP- * 129000 167000
800 AHA-08N4P*MP 134000 172000
1000 AH-10D-4CS-MP- * 138000 176000
1250 AH-12D-4CS-MP- * 168500 204500
1600 AH-16D-4CS-MP- * 186000 220000
2000 AHA-20N4P*MP 225100 260000
2000 AH-20D-4CS-MP- * POR POR
2500 AH-25D-4CS-MP- * 263500 295500
3200 AH-30D-4CS-MP- * 330000 360500
4000 AH-40D-4CS-MP- * 431500 462500
630 AH-6D-CS-MP- * 61000 89500
800 AH-8D-CS-MP- * 63500 98000
800 AHA-08N3P*MP 68500 103000
1000 AH-10D-CS-MP- * 68000 103500
1250 AH-12D-CS-MP-* 93000 127500
1600 AH-16D-CS-MP-* 96100 135500
2000 AHA-20N3P*MP 110500 151000
2000 AH-20D-CS-MP- * POR POR
2500 AH-25D-CS-MP- * 126500 166500
3200 AH-30D-CS-MP- * 196000 231500
4000 AH-40D-CS-MP- * 313000 343500
630 AH-6D-CS-MP- * 94200 132500
800 AH-8D-CS-MP- * 98000 133500
800 AHA-08N3P*MP 103000 138500
1000 AH-10D-CS-MP- * 107500 141000
1250 AH-12D-CS-MP-* 133500 165500
1600 AH-16D-CS-MP- * 141500 176500
2000 AHA-20N3P*MP 169500 204500
2000 AH-20D-CS-MP- * POR POR
2500 AH-25D-CS-MP- * 200000 231000
3200 AH-30D-CS-MP- * 265000 297500
4000 AH-40D-CS-MP- * 349000 381000
"D" series breakers fitted with standard accessories, tabulated below, are included in the Prices mentioned in the subsequent tables.
Manual Fixed (MF) Electrical Drawout (EDO)Manual Drawout (MDO)Electrical Fixed (EF)
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MF *EFReference
Unit Price (`)(`)(`)(`)(`)
* MF *EF
Rating(Amps)
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MDO *EDO
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MDO *EDO
ACB "D" SERIESACB "D" SERIESACB "D" SERIESACB "D" SERIESACB "D" SERIES
Notes : 1) In TP ACB if Earth Fault facility is required, add price of Neutral CTs from item no. 3 on page 12
2) If Under Voltage Release is required, add price of UVT Coil from item no. 7 on page 13
3) Prices of ACBs rating 5000 & 6300A available on request.
4) While ordering an ACB, the complete catalogue reference by replacing '*' with ACB type: MF - Manual Fixed,EF-Electrical Fixed, MD- Manual Drawout, ED-Electrical Drawout
5) All configured ACBs are non stockable. For further details please contact nearest branch office.
6) 3P & 4P MDO / EDO version ACBs with UVT 220V AC are available as stockable upto 2500A. For further details please contact nearest branch office.
7) ACBs with higher breaking capacities are also available on request.
800A ACB - 45 kA breaking capacity. 800A ACB - 50kA breaking capacity.# ACB with vertical terminals are available on request. N o n S t o c k a b l e i t e m
List Price w.e.f. 10th April 2009 11List Price w.e.f. 19th April 2011 11
Air Circuit Breaker "D" Series(III) ACB with Thermal Magnetic Release
Fixed, 4 Pole
Drawout 3 Pole Drawout, 4 Pole
- Thermal Magnetic Release
- Auxiliary Switch 5a 5b i.e 5NO+5NC
- Main CTs for 3 Phase only
- Shunt Trip
- Thermal Magnetic Release
- Auxiliary Switch 5a 5b i.e 5NO+5NC
- Main CTs for 3 Phase only
- AC/DC Charging Motor
- Closing Coil
- Shunt Trip
- Anti-pumping Relay
- Micro Switches as required for electrical operation
- Thermal Magnetic Release- Auxiliary Switch 5a 5b i.e 5NO+5NC- Main CTs for 3 Phase only- Safety Shutter- 36 way Auxiliary Isolating contacts- AC/DC Charging Motor- Closing Coil- Shunt Trip- Anti-pumping Relay- Micro Switches as required for
electrical operation- Terminal Type-Horizontal upto 2500A
& Vertical for 3200 / 4000A #
- Thermal Magnetic Release
- Auxiliary Switch 5a 5b i.e 5NO+5NC
- Main CTs for 3 Phase only
- Shunt Trip
- Safety Shutter
- 24 way Auxiliary Isolating contacts
- Terminal Type-Horizontal upto 2500A& Vertical for 3200 / 4000A #
"D" series breakers fitted with standard accessories, tabulated below, are included in the Prices mentioned in the subsequent tables.
LT Air Circuit Breaker fitted with Thermal Magnetic Release and Standard Accessories, as applicable.
630 AH-6D-4CS-TM- * 113500 153500
800 AH-8D-4CS-TM- * 114500 157500
800 AHA-08N4P*TM 119500 162500
1000 AH-10D-4CS-TM- * 125000 166000
1250 AH-12D-4CS-TM- * 153000 195000
1600 AH-16D-4CS-TM- * 170000 210000
2000 AHA-20N4P*TM 210000 246000
2000 AH-20D-4CS-TM- * POR POR
2500 AH-25D-4CS-TM- * 251000 284500
3200 AH-30D-4CS-TM- * 315000 347000
4000 AH-40D-4CS-TM- * 402000 439500
630 AH-6D-CS-TM- * 87000 120700
800 AH-8D-CS-TM- * 88000 121800
800 AHA-08N3P*TM 93000 126800
1000 AH-10D-CS-TM- * 96000 128200
1250 AH-12D-CS-TM- * 120500 152800
1600 AH-16D-CS-TM- * 134000 170000
2000 AHA-20N3P*TM 161000 196000
2000 AH-20D-CS-TM- * POR POR
2500 AH-25D-CS-TM- * 186000 219000
3200 AH-30D-CS-TM- * 250000 283000
4000 AH-40D-CS-TM- * 330000 368000
630 AH-6D-4CS-TM- * 68500 102500
800 AH-8D-4CS-TM- * 72000 106000
800 AHA-08N4P*TM 77000 111000
1000 AH-10D-4CS-TM- * 78500 116000
1250 AH-12D-4CS-TM- * 107000 149000
1600 AH-16D-4CS-TM- * 112300 154500
2000 AHA-20N3P*TM 135700 172000
2000 AH-20D-4CS-TM- * POR POR
2500 AH-25D-4CS-TM- * 156000 187500
3200 AH-30D-4CS-TM- * 232000 270000
4000 AH-40D-4CS-TM- * 339900 400000
Fixed, 3 Pole
630 AH-6D-CS-TM- * 50000 81200
800 AH-8D-CS-TM- * 53500 85000
800 AHA-08N3P*TM 58500 90000
1000 AH-10D-CS-TM- * 57000 92400
1250 AH-12D-CS-TM- * 82000 117000
1600 AH-16D-CS-TM- * 85000 127000
2000 AHA-20N3P*TM 99250 143500
2000 AH-20D-CS-TM- * POR POR
2500 AH-25D-CS-TM- * 112000 155000
3200 AH-30D-CS-TM- * 185500 224000
4000 AH-40D-CS-TM- * 287000 325500
Manual Fixed (MF) Electrical Drawout (EDO)Manual Drawout (MDO)Electrical Fixed (EF)
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MF *EF
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MF *EF
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MDO *EDO
Rating(Amps)
ReferenceUnit Price (`)(`)(`)(`)(`)
* MDO *EDO
ACB "D" SERIESACB "D" SERIESACB "D" SERIESACB "D" SERIESACB "D" SERIES
Notes : 1) While ordering an ACB without Over Current Release, Shunt trip & Main CTs, please deduct (`) 3000 for 630-1600A; (`) 6000 for 2000A; (`) 7000for 2500 - 3200A & (`) 8000 for 4000A from the prices listed above. Shunt trip will be standard in electrical ACB without release as well.
2) In TP ACB if Earth Fault facility is required, add prices of Earth Fault Relay from item no. 2 on page 12
3) If Under Voltage Release is required, add price of UVT Coil from item no. 7 on page 13
4) Prices of ACBs rating 5000 & 6300A available on request.
5) While ordering an ACB, the complete catalogue reference by replacing '*' with ACB type: MF - Manual Fixed,EF-Electrical Fixed, MD- Manual Drawout, ED-Electrical Drawout
6) All configured ACBs are non stockable. For further details please contact nearest branch office.
7) 3P & 4P MDO / EDO version ACBs with UVT 220V AC are available as stockable upto 2500A. For further details please contact nearest branch office.
8) ACBs with higher breaking capacities are also available on request.
800A ACB - 45 kA breaking capacity. 800A ACB - 50kA breaking capacity.# ACB with vertical terminals are available on request. N o n S t o c k a b l e i t e m
List Price w.e.f. 19th April 201112
6 Auxiliary Switch
6.1 5 way (2NO+3NC) Upto 1600A, AXH-2A3B-116
2000A-4000A, AXH-2A3B-220
5 way (3NO+2NC) Upto 1600A AXH-3A2B-1162000A - 4000A AXH-3A2B-220
930
6.2 10 way (5NO+5NC)Upto 1600A CS-AXH-5A5B-1162000A - 4000A CS-AXH-5A5B-220 1410
6.3 14 way (7NO+7NC)Upto 1600A CS-AXH-7A7B-1162000A - 4000A CS-AXH-7A7B-220 2320
4 FRP Laminated Safety Shutter Assembly
4.1 For 630A to 1600A ACB (3-Pole) ASH-1 1600
For 630A to 1600A ACB (4-Pole) ASH-1 (4P) 2040
4.2 For 2000A to 2500A ACB (3-Pole) ASH-2 1820
For 2000A to 2500A ACB (4-Pole) ASH-2 (4P) 2350
4.3 For 3200A ACB (3-Pole) ASH-3 2460
For 3200A ACB (4-Pole) ASH-3 (4P) 3530
4.4 For 4000A ACB (3-Pole) ASH-4 3030
For 4000A ACB (4-Pole) ASH-4 (4P) 3970
Air Circuit Breaker "B" Series
630 AH-6B-CS-TM- *
800 AH-8B-CS-TM- *
1000 AH-10B-CS-TM- * POR
1250 AH-12B-CS-TM- *
1600 AH-16B-CS-TM- *
Manual Fixed, 3 Pole with Thermal Magnetic Release
5 Auxiliary Isolating Contact Assembly (set of one contact block onACB side & two blocks on cradle side)
5.1
12 way
Upto 1600A, 3P AIH-1-116Upto 1600A, 4P AIH-1-116 (4P)2000A-2500A, 3P AIH-1-2202000A-2500A, 4P AIH-1-220 (4P)3200A-4000A, 3P AIH-1-3203200A-4000A, 4P AIH-1-320 (4P)
3290
5.2
24 way
Upto 1600A, 3P CS-AIH-2-116Upto 1600A, 4P CS-AIH-2-116 (4P)2000A-2500A, 3P CS-AIH-2-2202000A-2500A, 4P CS-AIH-2-220 (4P)3200A-4000A, 3P CS-AIH-2-3203200A-4000A, 4P CS-AIH-2-320 (4P)
4950
5.3
36 way
Upto 1600A, 3P CS-AIH-3-116Upto 1600A, 4P CS-AIH-3-116 (4P)2000A-2500A, 3P CS-AIH-3-2202000A-2500A, 4P CS-AIH-3-220 (4P)3200A-4000A, 3P CS-AIH-3-3203200A-4000A, 4P CS-AIH-3-320 (4P)
7070
2 Earth Fault Relay with NCT (For use with Thermal MagneticRelease)
2.1 Upto 1600A EFR116 4080
2.2 2000 - 2500A EFR225 4580
2.3 3200A EFR320 5240
2.4 4000A EFR400 5850
Main Accessories For D-type Air Circuit Breakers(Please specify ACB rating & type while placing order)
3 Single Phase Polyester Resin Cast CTs for D Series ACB - 1 CTper pole is required. In TP ACB, one additional CT will be required if, GroundFault Protection is selected.
3.1 250/5A ATB-024 ATB-024
3.2 400/5A ATB-044 ATB-040
3.3 630/5A ATB-064 ATB-060
3.4 800/5A ATB-084 ATB-080
1710
3.5 1000/5A ATB-104 ATB-110
3.6 1250/5A ATB-134 ATB-1201820
3.7 1600/5A ATB-164 ATB-160 2040
3.8 2000/5A ATB-220 ATB-220 2320
3.9 2500/5A ATB-225 ATB-225 2590
3.10 3200/5A ATB-332 ATB-332 3030
3.11 4000/5A ATB-440 ATB-440 4310
Note : * Spec i f y ACB Ra t i ng s .
1 ACB Protection Release (Micro Processor / Thermal)
1.1 Microprocessor release with L.T.D., S.T.D,μ IT - 100* 26500
Instantaneous, Ground Fault & LED Indication
1.2 Microprocessor release with L.T.D., S.T.D.μ IT - G* 25000
with LED Indication (for Generator Protection)
1.3 Thermal magnetic release CS-TOMCR 4100
Unit Price (`)(`)(`)(`)(`)*MFReference
Rating(Amps)
Unit Price( ` )( ` )( ` )( ` )( ` )
ReferenceDescriptionSl.No.
Sl.No.
Description ReferenceUnit Price
( ` )( ` )( ` )( ` )( ` )
Description Phase CT Neutral CTUnit Price( ` )( ` )( ` )( ` )( ` )
SI.NO.
DescriptionUnit Price( ` )( ` )( ` )( ` )( ` )
SI.NO.
Reference
ACB "B" SERIES
630 AH-6B-CS-MP- *
800 AH-8B-CS-MP- *
1000 AH-10B-CS-MP- * POR
1250 AH-12B-CS-MP- *
1600 AH-16B-CS-MP- *
Manual Fixed, 3 Pole with Microprocessor ReleaseUnit Price ((`)(`)(`)(`)(`)
*MFReference
Rating(Amps)
N o n S t o c k a b l e i t e m
"B" series breakers fitted with standard accessories, tabulated below, areincluded in the Prices mentioned in the subsequent tables.
- Themal Magnetic Release
- Auxiliary Switch 3NO+2NC
- Main CTs for 3 Phase only
- Shunt Trip only with thermal release
List Price w.e.f. 10th April 2009 13List Price w.e.f. 19th April 2011 13
Accessories For D-type Air Circuit Breakers(Please specify ACB rating & type while placing orders)
21 Making Current Release / Instantaneous Trip CS-MCR-1 5680 CS-MCR-2 6730 CS-MCR-3 7670
22 Mechanical Interlock (Fixed Vertical) MIL-16D-VF 6340 MIL-20D-VF 3640 MIL-32D-VF 8160
23 Mechanical Interlock (Fixed Horizontal) MIL-16D-HF 6340 MIL-20D-HF 6340 MIL-32D-HF 8160
24 Mechanical Interlock (D/o Vertical) MIL-16D-VDO 8940 MIL-20D-VDO 10230 MIL-32D-VDO 12240
25 Mechanical Interlock (D/o Horizontal) MIL-16D-HDO 8940 MIL-20D-HDO 10230 MIL-32D-HDO 12240
Unit Price( ` )( ` )( ` )( ` )( ` )
26Lifter with variable size Loader
LIFTER(for all sizes of ACBs)87150
27 Door Interlock (6D-16D) DOOR-INT-116 1880
28 Door Interlock (20D-40D) DOOR-INT-220 1880
29 Vertical Connection Copper Adapter CUADPTR-VC (6D~8D)
(6D~8D ) (2 per phase required)3530
30 Vertical Connection Copper Adapter CUADPTR-VC (10 D~12D)
(10D~12D) (2 per phase required)4190
31 Vertical Connection Copper Adapter CUADPTR-VC(16D)
(16D) (2 per phase required)4750
32 Vertical Connection Copper Adapter CUADPTR-VC (20 D~25D)
(20D~25D) (2 per phase required)9600
Code for Coils Voltage
AC 24/30V 48V 110V 220V- 415V-U V T / S T / C l o s i n g c o i l 240V 440V
- - - - FA MA NA
DC 24/30V 48V 110V 220V -
UVT - - - - FD MD -
ST / Closing coil B D E D FD MD -
8 Shunt Trip and Closing Coil
8.1 Shunt TripUpto 1600A CS-AVH-S-116 **2000A - 4000A CS-AVH-S-220 **
1820
8.2 Closing Coil
Upto 1600A CS-AVH-C-116 **2000A - 4000A CS-AVH-C-220 **
1820
**P lease spec i f y vo l tage wh i le o rde r i ng
7 Under Voltage Trip Device (D Series ACB) consisting of UVT Coil &Control device fitted in the ACB
Sl.No.
7.1 UVT Coil W/o Time DelayUpto 1600A CS-AUH-V-116 **2000A - 2500A CS-AUH-V-220 **3200A - 4000A CS-AUH-V-320 **
3750
UVT Coil with 500 msec. Time DelayUpto 1600A CS-AUH-V-T-116 **2000A - 2500A CS-AUH-V-T-220 **3200A - 4000A CS-AUH-V-T-320 **
4900
7.2 Direct Acting UVT Trip Coilwith series resistor for 30V DC
appl icat ion (630 - 1600A)
AUH-116DC2760
7.3 Direct Acting UVT Trip Coilwith series resistor for 30V DC AUH-220DC
application (2000 - 4000A)4580
S. No. 22, 23, 24 & 25 will be supplied only factory fitted. These can not be fitted at site thus always order with ACB only.
9 OCR (Fault) Alarm Switch (for ACB with MicroProcessor release only) ALA-1 530 ALA-2 530
10 Trip Indication Switch (For manual and Fault tripping in ACB with TM release only) TIS -1 530 TIS-2 530
11 'Spring Charged' Indication Switch SCIS 700 SCIS 700
12 Position Indication Switch ALB-4P-116 1710 ALB-IP-220 1710
13 Close Open Cycle Counter ASC-1 1600 ASC-2 1600
14 Key Lock (One lock + One key) AK1-116D 1220 AKI-220D 1220
15 Castle Key Lock CKI-116 3700 CKI-220 3700
16 Key Interlock (Consisting of 3-Key Locks with 2 Keys (same No.) fitted on 3 ACBs) AKI-1-116 3310 AKI-1-220 3310
17 Key Interlock (Consisting of 2-Key Locks with 1 Key (same No.) fitted on 2 ACBs) AKI-2-116 2510 AKI-2-220 2510
18 Short Circuit Contact for Shunting Auxiliary Isolating Contacts whenACB w i thd rawn
SCC 290 SCC 290
19 Rectifier Unit 240V AC / 24V DC, used for LED Indication or for functionchecking of Microprocessor Release (Can Control Upto 5 no. of ACBs)
CS-ARO-1BMA 1700 CS-ARO-1BMA 1700
20 Rectifier Unit 415V AC / 24V DC, used for LED Indication or for functionchecking of Microprocessor Release (Can Control Upto 5 no. of ACBs)
CS-ARO-1BNA 1700 CS-ARO-1BNA 1700
Description ReferenceUnit Price( ` )( ` )( ` )( ` )( ` )
Sl.No.
For Air Circuit Breaker ReferenceUnitPrice( ` )( ` )( ` )( ` )( ` )
6D - 16DReference
DescriptionSl.No.
Suitable for ACB frame size / rating
Unit Price( ` )( ` )( ` )( ` )( ` )
20D - 40DReference
Unit Price( ` )( ` )( ` )( ` )( ` )
30D - 40DReference
Unit Price( ` )( ` )( ` )( ` )( ` )
20D - 25DReference
Unit Price( ` )( ` )( ` )( ` )( ` )
6D - 16DReference
Suitable for ACB frame size / ratingDescriptionSl.
No.
ACCESSORIES - ACB
N o n S t o c k a b l e i t e m
List Price w.e.f. 19th April 201114
Spares For D-type Air Circuit Breakers
34 Arcing Contacts (Set of 1 no. fixed & 1 no. moving)
35 Main Isolating Contacts (Jaw Contacts)
39 Main Moving Contacts Assembly
Note : " * " To arrive at total quantity per ACB, multiply by 3 or 4depending upon number of poles in the ACB.
630A ARCCONT-06D
800A ARCCONT-08D 1M / 1F3370
1000A ARCCONT-10D
1250A ARCCONT-12D 1M / 1F3650
1600A ARCCONT-16D 1M / 1F 4270
2000A ARCCONT-20D 1M / 1F 5340
2500A ARCCONT-25D 1M / 1F 7420
3200A ARCCONT-30D 1M / 1F 8370
4000A ARCCONT-40D 3M / 1F 10390
Note: M - Moving, F - Fixed
630A M I C - 0 6 D 2
800A M I C - 0 8 D 25490
1000A M I C - 1 0 D 2
1250A M I C - 1 2 D 26130
1600A M I C - 1 6 D 2 7220
2000A M I C - 2 0 D 2 15940
2500A M I C - 2 5 D 2 23680
3200A M IC-30D 2 25410
4000A M I C - 4 0 D 2 28360
36 Main Fixed Contacts (Upper Terminals)
630A-800A FIXCONT-06D-08D 1 5050
1000A-1250A FIXCONT-10D-12D 1 5370
1600A FIXCONT-16D 1 5490
2000A FIXCONT-20D 1 6880
2500A FIXCONT-25D 1 9360
3200A FIXCONT-30D 1 21710
4000A FIXCONT-40D 1 27310
37 Lower Terminals with fitting plates630A LWR-TRNL-6B-6D 1 5030
800A LWR-TRNL-8B-8D 1 5490
1000A LWR-TRNL-10B-10D 1
1250A LWR-TRNL-12B-12D 16010
1600A LWR-TRNL-16B-16D 1 6670
2000A LWR-TRNL-20C-20D 1 8370
2500A LWR-TRNL-25C-25D 1 8780
3000A LWR-TRNL-30C-30D 1 16580
4000A LWR-TRNL-40C-40D 1 22690
630A -800A MOVMAIN-06D-08D 1 3750
1000A-1250A MOVMAIN-10D-12D 1 3980
1 6 0 0 A M O V M A I N - 1 6 D 1 5830
2 0 0 0 A M O V M A I N - 2 0 D 1 7740
2 5 0 0 A M O V M A I N - 2 5 D 1 10160
3 2 0 0 A M O V M A I N - 3 0 D 1 23220
4 0 0 0 A M O V M A I N - 4 0 D 1 31080
33 Drawout Mould Base (Cradle Side)
38 Circuit Terminals / Drawout Terminals630A CKTTML-06D 2
800A CKTTML-08D 23360
1000A CKTTML-10D 2
1250A CKTTML-12D 24970
1600A CKTTML-16D 2 7980
2000A CKTTML-20D 2 7980
2500A CKTTML-25D 2 11720
3200A CKTTML-30D 2 23220
4000A CKTTML-40D 2 29340
Moving ArcingContact
Main MovingContact
Assembly
Lower Terminal AssemblyCircuit (Drawout)
Terminals
DrawoutMould Base
Main Isolating Contacts(Jaw Contacts)
Fixed Arcing Contact
Main Fixed Contact(Upper Terminals)
(Please specify ACB rating & type while placing order for spares)
1) Items for Drawout ACB.2) Horizontal arrangement
(as shown) upto 2500A& vertical for higherrating.
630A DRMOULD-06D 2
800A DRMOULD-08D 2
1000A DRMOULD-10D 2
1250A DRMOULD-12D 2
1600A DRMOULD-16D 2
1220
2000A DRMOULD-20D 2
2500A DRMOULD-25D 21880
3200A DRMOULD-30D 1 4140
4000A DRMOULD-40D 1 4750
For ACBRating
ReferenceQty. Required
Per Phase*Unit Price( ` )( ` )( ` )( ` )( ` )
For ACBRating Reference
Qty. RequiredPer Phase*
Unit Price( ` )( ` )( ` )( ` )( ` )
SPARES - ACB
N o n S t o c k a b l e i t e m
List Price w.e.f. 10th April 2009 15List Price w.e.f. 19th April 2011 15
Spares For D-type Air Circuit Breakers(Please specify ACB rating & type while placing order for spares)
40 Complete Pole Unit (Common for 3 & 4 Pole ACBs) Other Spares
Note : "*" New developed Microswitch
"**" Please specify ACB rating & type while ordering for spares.
41 Arc Chutes
630A-1600A ARCCHT-06D-16D 1 2210
2000A ARCCHT-20D 1 2870
2500A ARCCHT-25D 1 3360
3200A ARCCHT-30D 1 7280
4000A ARCCHT-40D 1 7770
" *" To arrive at total quantity per ACB, multiply by 3 or 4 depending uponnumber of poles in the ACB.
42. New Style Micro Switch for Motor 630A-4000A MICROSW * 780
43. Anti Pumping Relay 630A-4000A
Upto 1600A, 3P CS-ANTPUMPRLY-116 **
Upto 1600A, 4P CS-ANTPUMPRLY-116 (4P) **
2700
2000A-2500A, 3P CS-ANTPUMPRLY-220 **2000A-2500A, 4P CS-ANTPUMPRLY-220 (4P) ** 2980
3200A-4000A, 3P CS-ANTPUMPRLY-320 **3200A-4000A, 4P CS-ANTPUMPRLY-320 (4P) ** 3140
44. Manual Charging Handle 630A-1600A MCLHND-6D-16D 2150
45. Manual Charging Handle 2000A-4000A MCLHND-20D-40D 2320
46. Drawout Handle 630A-1600A DRHND-6D-16D 1760
47. Drawout Handle 2000A-4000A DRHND-20D-40D 2150
48. Magnet Hold Trigger 6D-16D MHT-16D 2320
49. Magnet Hold Trigger 20D-25D MHT-20D-25D 3030
50. Magnet Hold Trigger 30D-40D MHT-30D-40D 3310
51. D/O Telescopic Rail (L)
Upto 1600A DRTLRAIL (L) - 1
2000A - 2500A DRTLRAIL (L) - 2
3200A - 4000A DRTLRAIL (L) - 3
830
52. D/O Telescopic Rail (R)
Upto 1600A DRTLRAIL (R) - 1
2000A - 2500A DRTLRAIL (R) - 2
3200A - 4000A DRTLRAIL (R) - 3
830
54 *Auxiliary Isolating Contact Blocks
Breaker & Cradle Side 12 Way AIH-BC 3260
53 Charging Motors (110V AC/DC) or (220V AC/DC)
630-1600 AMH-1 16260
2000-4000 AMH-2 21170
**Voltage Code for Antipumping Relay
24/30V 48V 110V 220V 415V
AC - - - - FA MA NA
DC B D E D FD MD -
*Auxiliary Isolating Contact Blocks has to be order together forCradle & Breaker side.
Pole Unit
Arc Chute
40.1 Single Pole unit for 630 A COND UNIT-6D 10160
40.2 Single Pole unit for 800 A COND UNIT-8D 11090
40.3 Single Pole unit for 1000 A COND UNIT-10D 12130
40.4 Single Pole unit for 1250 A COND UNIT-12D 14270
40.5 Single Pole unit for 1600 A COND UNIT-16D 16520
40.6 Single Pole Unit for 2000 A COND UNIT-20D 22300
40.7 Single Pole Unit for 2500 A COND UNIT-25D 24150
40.8 Single Pole Unit for 3200 A COND UNIT-30D 48400
40.9 Single Pole Unit for 4000 A COND UNIT-40D 57640
For Air Circuit Breaker ReferenceUnit Price( ` )( ` )( ` )( ` )( ` )
Sl.No.
ReferenceUnit Price( ` )( ` )( ` )( ` )( ` )
For ACBRating (Amp)
Qty. RequiredPer Phase *
UnitPrice( ` )( ` )( ` )( ` )( ` )
ReferenceDescriptionSl.
No.
For Air Circuit BreakerRating (A) Reference Unit Price
( ` )( ` )( ` )( ` )( ` )
Description Reference Unit Price( ` )( ` )( ` )( ` )( ` )
SPARES - ACB
55 Communication Module
Communication Module for
Micropro 4.1 Release
Description Reference Unit Price( ` )( ` )( ` )( ` )( ` )
PSCM-Micropro POR
List Price w.e.f. 19th April 201116
RELE
ASE
S
Please fill seperate sheet for each type of ACB. Tick the box in front of each appropriate item and fill in the blanks.
CUSTOMER NAME ORDER NO. & DATE DELIVERY DATE
Notes : (1) Please refer catalogue / Price-List, for further details of μIT - 100 / μIT - G Releases.
(2) Neutral CT is required alongwith Microprocessor Release having Ground -Fault Protection. This has to be mounted onEarth / Neutral Busbar of Panel.
QTY. (NOS.)630 A 1000 A 1600 A 2500 A 4000 A 6300 A
800 A 1250 A 2000 A 3200 A 5000 A
3 POLE 4 POLE AMBIENT TEMP.
RATINGOF ACB
REQUIRED
NO. OFPOLES 40 0C 50 0C
WITHOUT RELEASES
12/24/36 WAY AUX. ISOLATING CONTACT ASSLY.
POSITION INDICATION SWITCH
SHORT CIRCUIT CONTACTS ______ NOS / ACB
CLOSING COIL ______ V AC / ______ V DC
SHUNT TRIP COIL ______ V AC / ______ V DC
MOTOR 240V AC 220V DC
110V AC 110V DCOPE
RATI
ON
MO
UNTIN
G
FIXED DRAWOUT
MANUAL ELECTRICAL
UNLE
SS &
OTH
ERW
ISE
SPEC
IFIE
D,
ALL
SETT
ING
S O
F RE
LEAS
ES W
OUL
D
BE S
ET A
T M
INIM
UM V
ALUE
S.
THERMAL MAGNETIC
μIT-100 μIT-G
MICROPROCESSORRELEASE
EARTHFAULT REQD. NOT REQD.
SHUNT TRIP ______ V AC/ ______ V DC
(220V AC SHUNT TRIP IS PROVIDED AS STANDARD)
REQUIRED MAIN CT RATING _________ A
SETTING OF NON-ADJ. MAG. INST. TRIP _________ KA
MAIN CT RATING _____________ A, NEUTRAL CT RATING _________ A,
SETTINGS : OVERLOAD ________ A, SHORT CIRCUIT _________ A,
GROUND FAULT _______ A
AC
CES
SORI
ES
SPECIAL REQUIREMENT/ACCESSORIES (IF ANY)
AC DC
2 ACBs
3 ACBs
AUX. SW. 3 NO + 2 NC AUX. SW. 5 NO + 5 NC AUX. SW. 7 NO + 7 NC
TRIP IND. SWITCH OCR ALARM SWITCH SPRING CHARGE IND. SWITCH
POSITION IND. SWITCH CASTLE KEYLOCK SHUNT TRIP ______ VOLTS
KEY LOCK KEY INTERLOCK
UVT-AUH. ________ V, CLOSE-OPEN CYCLE COUNTER
MECHANICAL INTERLOCK
DOOR INTERLOCKHOR. VER.
DC ACDELAY
NO DELAY
( IF NOT SPECIFIED, 220V AC IS SUPPLIED )
END USER / PANEL BUILDER NAME & PHONE NO.
ACB ORDER FORM
Pro 4.1 Pro 5.1WITH COMMUNICATION MODULE
WITHOUT COMMUNICATION MODULE
BATTERY UNIT
List Price w.e.f. 19th April 201118
Normal Duty
1.0 CSPND0001440 440 V 250.0 250
2.0 CSPND0002440 440 V 250.0 500
3.0 CSPND0003440 440 V 250.0 750
4.0 CSPND0004440 440 V 250.0 1000
5.0 CSPND0005440 440 V 125.0 265
7.5 CSPND0075440 440 V 125.0 938
10.0 CSPND0010440 440 V 125.0 1250
12.5 CSPND0125440 440 V 125.0 1562
15.0 CSPND0015440 440 V 125.0 1875
20.0 CSPND0020440 440 V 125.0 2500
25.0 CSPND0025440 440 V 125.0 3125
RatingkVar
ReferenceUnit Price( ` )( ` )( ` )( ` )( ` )
RatedVoltage
LP / kVar
Super Heavy Duty
1.0 CSSHD0001440 440 V 325.0 325
2.0 CSSHD0002440 440 V 325.0 650
3.0 CSSHD0003440 440 V 325.0 975
4.0 CSSHD0004440 440 V 325.0 1300
5.0 CSSHD0005440 440 V 290.0 1450
7.5 CSSHD0075440 440 V 290.0 2175
10.0 CSSHD0010440 440 V 290.0 2900
12.5 CSSHD0125440 440 V 290.0 3265
15.0 CSSHD0015440 440 V 290.0 4350
20.0 CSSHD0020440 440 V 290.0 5800
25.0 CSSHD0025440 440 V 290.0 7250
50.0 CSSHD0050440 440 V 290.0 14550
RatingkVar
ReferenceRated
VoltageLP / kVar
CAPCAPCAPCAPCAPAAAAACITORCITORCITORCITORCITOR
Note: C a p a c i t o r s a r e a l s o a v a i l a b l e i n 4 1 5 / 4 8 0 / 5 2 5 V.F o r f u r t h e r d e t a i l s p l e a s e c o n t a c t n e a r e s t b r a n c h o f f i c e .
Unit Price( ` )( ` )( ` )( ` )( ` )
Normal Duty
1.0 CSSND0001440 440V 255.0 255
2.0 CSSND0002440 440V 255.0 510
3.0 CSSND0003440 440V 255.0 765
4.0 CSSND0004440 440V 255.0 1020
5.0 CSSND0005440 440V 155.0 775
7.5 CSSND0075440 440V 155.0 1162
10.0 CSSND0010440 440V 155.0 1550
12.5 CSSND0125440 440V 155.0 1937
15.0 CSSND0015440 440V 155.0 2325
20.0 CSSND0020440 440V 155.0 3100
25.0 CSSND0025440 440V 155.0 3875
50.0 CSSND0050440 440V 155.0 7800
RatingkVar
ReferenceRated
VoltageLP / kVar
Unit Price( ` )( ` )( ` )( ` )( ` )
Heavy Duty
1.0 CSPHD0001440 440 V 265.0 265
2.0 CSPHD0002440 440 V 265.0 530
3.0 CSPHD0003440 440 V 265.0 795
4.0 CSPHD0004440 440 V 265.0 1060
5.0 CSPHD0005440 440 V 210.0 1050
7.5 CSPHD0075440 440 V 210.0 1575
10.0 CSPHD0010440 440 V 210.0 2100
12.5 CSPHD0125440 440 V 210.0 2625
15.0 CSPHD0015440 440 V 210.0 3150
20.0 CSPHD0020440 440 V 210.0 4200
25.0 CSPHD0025440 440 V 210.0 5250
RatingkVar Reference
RatedVoltage LP / kVar
N o n S t o c k a b l e i t e m
Unit Price( ` )( ` )( ` )( ` )( ` )
Cylindrical Capacitor Rectangular Capacitor
CYLINDRICAL CAPACITOR
RECTANGULAR CAPACITOR
List Price w.e.f. 19th April 2011 19
Push Buttons (Metallic Series): 22.5mmWithout Contact ElementsPush Button Actuators with Carrier - Non-Illuminated
Description ReferenceUnit Std.Price Pkg.((((( `̀̀̀̀ ))))) (No's)
Flush Spring Return RCB2-BA1 Push Button RCB2-BA2
RCB2-BA3 RCB2-BA4 RCB2-BA5 RCB2-BA6
44 20
Projecting Push Button RCB2-BL1 RCB2-BL2 RCB2-BL3 RCB2-BL4 RCB2-BL5 RCB2-BL6
47 20
Booted Push Button RCB2-BP2 RCB2-BP3 RCB2-BP4 RCB2-BP5 RCB2-BP6
74 20
Mushroom Head Push Button, RCB2-BC2 Spring Return RCB2-BC3
RCB2-BC4 RCB2-BC5 RCB2-BC6
74 8
Mushroom Head Push RCB2-BS54 103 8Button Stay Put (press to RCB2-BS64
139 5lock, turn to release)Mushroom Head Push Button,Push to Stay & Pull to release RCB2-BT4
113 8
Mushroom Head Key Switch, StayPut, Key removable in both positions RCB2-BSI4 198 8(press to lock and key to release)Push Button Stay Put (press RCB2-BS44
98 10to lock, turn to release)
ProductPicture
LED Type Push Button Actuators - Illuminated Flush
▲Add Voltage Code, Operating voltage available in 240V AC & 220V DC
LED Type Push Button Actuators - Illuminated ProjectingType of voltage AC/DC to be specified
▲ Add Voltage Code Operating Voltage available in 240V AC & 220V DC
Projecting Illuminated Actuator, RCB2-BWL137▲
with integral circuit and cluster RCB2-BWL147▲LED, suitable for operating at RCB2-BWL157▲ 149 10240V , 220V, 110V, 48V, 24V & 12VProjecting Illuminated Actuator,with integral circuit and cluster RCB2-BWL167▲ 355 10LED, suitable for operating at240V , 220V , 110V, 48V, 24V & 12V
Push Button Actuators - Illuminated Projectingwithout Series Resistor
Illuminated Actuator, Projecting RCB2-BW116▲
(with BA9S Filament Bulb) RCB2-BW136▲
12V, 24V, 48V, 110V AC / DC RCB2-BW146▲
RCB2-BW156▲
RCB2-BW166▲
RCB2-BW176▲
Illuminated Actuator, Projecting RCB2-BWN136▲
(with BA9S Neon Bulb) RCB2-BWN146▲
220V, 380V, 415V AC / DC RCB2-BWN156▲
108 10
Flush Illuminated Actuator, RCB2-BWL337▲
with integral circuit and cluster RCB2-BWL347▲LED, suitable for operating at RCB2-BWL357▲ 149 10240V , 220V , 110V,48V, 24V & 12VFlush Illuminated Actuator,with integral circuit and clusterLED, suitable for operating at RCB2-BWL367▲ 247 10240V , 220V , 110V,48V, 24V & 12V
φ40mmφ60mm
Double Push Button Actuators with Carrier - FlushDouble Push Button,FlushGreen & Red Knob markedI&O respectively RCB2-BA87 88 10
▲Add Voltage Code
Double Push Button Actuators - Illuminated Flushwithout Series Resistor
Illuminated Double Push Button,Flush Green & Red Knob markedI&O respectively (with BA9SNeon Bulb) 220V, 380V, 415V AC / DC RCB2-BWN96▲ 154 8
▲Add Voltage Code
Push Button Actuators - Illuminated Projectingwith Series Resistor
Illuminated Actuator, Projecting RCB2-BW117▲
(with BA9S Filament Bulb,130V) RCB2-BW137▲
220V AC / DC RCB2-BW147▲
RCB2-BW157▲
RCB2-BW167▲
RCB2-BW177▲
113 10
▲ Add Voltage Code
Push Button Actuators-Illuminated Flush without Series ResistorIlluminated Actuator, Flush RCB2-BW316▲(with BA9S Filament Bulb) RCB2-BW336▲12V, 24V, 48V, 110V AC/DC RCB2-BW346▲
RCB2-BW356RCB2-BW366▲RCB2-BW376▲
Illuminated Actuator, Flush RCB2-BWN336▲(with BA9S Neon Bulb) RCB2-BWN346▲220V, 380V, 415V AC/DC RCB2-BWN356▲
113 10
Illuminated Actuator, Flush RCB2-BW317▲(with BA9S Filament Bulb, 130V) RCB2-BW337▲220V AC/DC RCB2-BW347▲
RCB2-BW357▲RCB2-BW367▲RCB2-BW377▲
121 10
Push Button Actuators - Illuminatedwith Series Resistor
Mushroom head push button RCB2-BW437illuminated (with BA9S Filament RCB2-BW447
247 8
Bulb, 130V) 220V AC/DC- 2 position Momentary
- 2 position Maintained RCB2-BW637RCB2-BW647
283 8
Mushroom Head Actuators - Illuminated
φ40mm
▲ Add Voltage Code
GLOBAL CERTIFICATION
φ30mm
Push Button Actuators with Carrier & Contact Element-Non-Illuminated
Flush Spring Return RCB2-BA11 Push Button with 1NO Block RCB2-BA21
RCB2-BA31 RCB2-BA51 RCB2-BA61 RCB2-BA41 RCB2-BA42
82 10
Projecting Head Push Button RCB2-BL11 with 1NO Block RCB2-BL21
RCB2-BL31 RCB2-BL51 RCB2-BL61 RCB2-BL42
84 10
Mushroom Head Push RCB2-BS542 139 8Button Stay Put (press tolock, turn to release)with 1NC Block
Description ReferenceUnit Std.Price Pkg.((((( `̀̀̀̀ ))))) (No's)
ProductPicture
φ40mmφ60mm RCB2-BS642 175 5
Push Button with 1NC Block
Projecting PB with 1NC Block
PUSH BUTTON
20 List Price w.e.f. 19th April 2011
Selector Actuators (Metallic Series): 22.5mmWithout Contact Elements
How to Order :Actuators, Contact Elements, Lens Assemblies can also be ordered separatelyor in combination, as required.
Voltage Code for Pilot Lamps
Voltage Code 12V 24V 48V 110V 220V 240V 380V 415V
AC JA BA EA FA MA UA QA NA
DC JD BD ED FD MD - Q D ND
Key Actuators with Carrier
2-Position Key Switch, Keyremovable in unactuated position RCB2-BG2
2-Position Key Switch, Keyremovable in both position RCB2-BG4
2-Position Key Switch, Keyremovable in 'Right Hand' position RCB2-BG02
3-Position Key Switch, Keyremovable in centre 'OFF' position RCB2-BG3
3-Position Key Switch, Keyremovable in all position RCB2-BG0
3-Position Key Switch, Key removablein 'Left Hand & Right Hand ' position RCB2-BG5
3-Position Key Switch, Key removablein 'Left Hand' position RCB2-BG9
3-Position Key Switch, Key removablein 'Right Hand' position RCB2-BG09
3-Position (Spring Return) Key Switch,Key removable in 'Center' position RCB2-BG7
Contact Elements - NO/NCContact Element 1 NO RB2- BE-101
Contact Element 1 NC RB2- BE-10241 50
Selector Switch Actuators with Carrier
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
ProductPicture
2-Position Selector Switch (stay put) RCB2-BD23-Position Selector Switch,centre 'OFF' (stay put) RCB2-BD3
139
2-Position Selector Switch withextra long knob (stay put) RCB2-BJ23-Position Selector Switch, with extralong knob centre 'OFF' (stay put) RCB2-BJ3
144
2-Position Selector Switch(Spring Return) RCB2-BDR23-Position Selector Switch(Spring Return) RCB2-BDR3
159
2-Position Selector Switchextra long knob (Spring Return) RCB2-BJR23-Position Selector Switchextra long knob (Spring Return) RCB2-BJR3
164
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
ProductPicture
1. Push Button & Selector Switch Actuators also available with Black Bezel onrequest.
2. To order add suffix 7 to the product code. e.g RCB2-BA4 will becomeRCB2-BA47.
Selector Switch Actuators - Illuminatedwith series resistor
2-Position Illuminated Selector RCB2-BK1237▲
Switch (with BA9S Filament Bulb RCB2-BK1247▲
130V) suitable for operation RCB2-BK1257▲
at 220V AC / DC
3-Position Illuminated Selector RCB2-BK1337▲
Switch (with BA9S Filament Bulb RCB2-BK1347▲
130V) suitable for operation RCB2-BK1357▲
at 220V AC / DC
▲ Add Voltage Code
Selector Switch Actuators - Illuminatedwithout series resistor
2-Position Illuminated Selector RCB2-BK1236▲
Switch (with BA9S Filament Bulb) RCB2-BK1246▲
24V, 48V, 110V AC/DC RCB2-BK1256▲215
3-Position Illuminated Selector RCB2-BK1336▲
Switch (with BA9S Filament Bulb) RCB2-BK1346▲
24V, 48V, 110V AC/DC RCB2-BK1356▲
215
2-Position Illuminated Selector RCB2-BKN1236▲
Switch (with BA9S Neon Bulb) RCB2-BKN1246▲
suitable for operation at 220V, RCB2-BKN1256▲
215
380V, 415V AC / DC
3-Position Illuminated Selector RCB2-BKN1336▲
Switch (with BA9S Neon Bulb) suitable RCB2-BKN1346▲
for operation at 220V, 380V, RCB2-BKN1356▲
215
415V AC / DC
▲ Add Voltage Code
Colour Code 1 2 3 4 5 6 7
Colour of Actuator White Black Green Red Yellow Blue —
Colour of Lens White — Green Red Amber Blue Clear
Colour Code for Actuator / Lens
Key Actuators with Carrier & Contact element
2-Position Key Switch with 1NO Block,Key removable in unactuated position RCB2-BG21
2-Position Key Switch with 1NO Block, RCB2-BG41Key removable in both position
230
3-Position Key Switch with 1NO+1NC Blockkey removable in centre 'OFF' position
RCB2-BG31 270
3-Position Key Switch with 1NO+1NC Block RCB2-BG04key removable in all position
270
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
Selector Switch Actuators with Carrier & Contact Element
2-Position Selector Switch(stay put) with 1NO Block
RCB2-BD21 175
2-Position Selector Switch,centre 'OFF' (stay put) withNO+NC Block
RCB2-BD25 210
3-Position Selector Switch,centre 'OFF' (stay put) withNO+NC Block
RCB2-BD35 210
Selector Switch Actuators-IIIuminated with integral circuit LED available on request
ProductPicture
10
10
215 10
10
10
195
200
10
PUSH BUTTON
List Price w.e.f. 19th April 2011 21
Pilot Lamps (Metallic Series): 22.5mmGLOBAL CERTIFICATION
Pilot Lamps with Series Resistor & Diode
Pilot Lamp (with BA9S Filament RCB2-BVD71▲
Bulb 130V) 240V AC RCB2-BVD73▲
RCB2-BVD74▲
RCB2-BVD75▲
RCB2-BVD76▲
RCB2-BVD77▲
▲Add Voltage Code
Note : Please mention supply voltage of Pilot Lamps, Pilot LightBody Assemblies and Illuminated Push Buttons with productreference while ordering.
Voltage Code for Pilot Lamps
Voltage Code 12V 24V 48V 110V 220V 240V 380V 415V
AC JA BA EA FA MA UA QA NA
DC JD BD ED FD MD - Q D ND
Integrated LED Pilot LampType of voltage AC/DC to be specified
▲ Add Voltage Code, Operating voltage available in 110, 240V AC & 110,220V DC
Description Reference Unit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
Integral LED pilot Lamp RCB7-IVL73▲
suitable for operating at RCB7-IVL74▲110&240V , 110&220V , RCB7-IVL75▲48V, 24V & 12V RCB7-IVL77▲
RCB7-IVL78▲
RCB7-IVL76▲
RCB7-IVL71▲196 15
ProductPicture
10103
1598
PUSH BUTTON
ProductPicture
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
Red/Green 12V AC /DC RCB7IVL73412
Red/Green 24V AC /DC RCB7IVL73424
Red/Green 48V AC /DC RCB7IVL73448
Red/Green 110V AC /DC RCB7IVL734110
Red/Green 240V AC /DC RCB7IVL734240
Red/Blue 12V AC /DC RCB7IVL74612
Red/Blue 24V AC /DC RCB7IVL74624
Red/Blue 48V AC /DC RCB7IVL73648 150 15
Red/Blue 110V AC /DC RCB7IVL746110
Red/Blue 240V AC /DC RCB7IVL746240
Red/White 12V AC /DC RCB7IVL71412
Red/White 24V AC /DC RCB7IVL71424
Red/White 48V AC /DC RCB7IVL71448
Red/White 110V AC /DC RCB7IVL714110
Red/White 240V AC /DC RCB7IVL714240
NEW
Integrated Dual Colour LED Pilot Lamps
ProductPicture
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
Pilot Lamps with Series ResistorPilot Lamp (with BA9S Filament RCB2-BV71▲
bulb 130V) 220V AC / DC RCB2-BV73▲RCB2-BV74▲RCB2-BV75▲RCB2-BV76▲RCB2-BV77▲
▲ Add Voltage Code
LED Type Pilot LampType of voltage AC/DC to be specified
Pilot Light with integral circuit & RCB2-BVL73▲
cluster LED, suitable for RCB2-BVL74▲
operating at 240V , 220V , RCB2-BVL75▲128 10
110V, 48V, 24V & 12V RCB2-BVL77▲
Pilot Light with integral circuit &
cluster LED, suitable forRCB2-BVL76▲ 260 10operating at 240V , 220V ,
110V, 48V, 24V & 12V
▲Add Voltage Code, Operating voltage available in 240V AC & 220V DC
▲ Add Voltage Code
Pilot Lamps with TransformerPilot Lamp (with BA9S Filament RCB2-BV41▲
Bulb) for Input Voltage : 240V AC RCB2-BV43▲
and Output Voltage : 6V AC RCB2-BV44▲
RCB2-BV45▲
RCB2-BV46▲
RCB2-BV47▲
Pilot Lamp (with BA9S Filament RCB2-BV31▲
Bulb) for Input Voltage : 110V AC RCB2-BV33 ▲
and Output Voltage : 6V AC RCB2-BV34▲
RCB2-BV35▲
RCB2-BV36▲
RCB2-BV37▲
1098
8245
ProductPicture
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
Yellow/Green 12V AC /DC RCB7IVL73812
Yellow/Green 24V AC /DC RCB7IVL73824
Yellow/Green 48V AC /DC RCB7IVL73848
Yellow/Green 110V AC /DC RCB7IVL738110
Yellow/Green 240V AC /DC RCB7IVL738240
Yellow/Blue 12V AC /DC RCB7IVL76812
Yellow/Blue 24V AC /DC RCB7IVL76824
Yellow/Blue 48V AC /DC RCB7IVL76848 150 15
Yellow/Blue 110V AC /DC RCB7IVL768110
Yellow/Blue 240V AC /DC RCB7IVL768240
Yellow/White 12V AC /DC RCB7IVL71812
Yellow/White 24V AC /DC RCB7IVL71824
Yellow/White 48V AC /DC RCB7IVL71848
Yellow/White 110V AC /DC RCB7IVL718110
Yellow/White 240V AC /DC RCB7IVL718240
Integrated Dual Colour LED Pilot Lamps
NEW
22 List Price w.e.f. 19th April 2011
Accessories (Metallic Series)For Push Buttons & Pilot Lamps : 22.5mm
Operating Heads Without Contact Block and CarrierOperating Heads LED, Neon Pilot Lamp / Push ButtonWithout Contact Block and Carrier
Operating Heads Without Contact Block and Carrier
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
Pilot Lamp Head RB2-BVO1
RB2-BVO3
RB2-BVO4
RB2-BVO5
RB2-BVO6
RB2-BVO7
Flush Push Button RB2-BA1
RB2-BA2
RB2-BA3
RB2-BA4
RB2-BA5
RB2-BA6
Projecting Push Button RB2-BL1
RB2-BL2
RB2-BL3
RB2-BL4
RB2-BL5
RB2-BL6
Mushroom Spring Return RB2-BC2
RB2-BC3
RB2-BC4
RB2-BC5
RB2-BC6
Mushroom Stay Put RB2-BS44 85 10
RB2-BS54 95 08
RB2-BS64 125 05
Mushroom illuminated- 2 position Momentary RCB2-BW43
RCB2-BW44160 08
- 2 position Maintained RCB2-BW64RCB2-BW63
190 08
Booted Push Button RB2-BP2
RB2-BP3
RB2-BP4 70 20
RB2-BP5
RB2-BP6
Double Headed without Light RB2-BA87 80 10
Double Headed Push Button
with Light RB2-BW990 10
Illuminated Flush Push Button RB2-BW33
RB2-BW34
RB2-BW35
RB2-BW36
RB2-BW37
Illuminated Projecting Push Button RB2-BW13
RB2-BW14
RB2-BW15
RB2-BW16
RB2-BW17
Illuminated Selector 2-Position RB2-BK123
Stay Put RB2-BK124
RB2-BK125 135 10
Illuminated Selector 3-Position RB2-BK133
Stay Put RB2-BK134 150 10
RB2-BK135
ProductPicture Description Reference
Unit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
LED Pilot Lamp Head RB2-BVLO3
RB2-BVLO4
RB2-BVLO5
RB2-BVLO6
LED Illuminating Flush Push Button RB2-BWL33
RB2-BWL34
RB2-BWL35
RB2-BWL36
LED Illuminating Projecting P button RB2-BWL13
RB2-BWL14
RB2-BWL15
RB2-BWL16
ProductPicture
Description ReferenceOperating
Unit Std.
HandlePrice Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
Selector 2-Position, RB2-BD2 Standard 129Stay Put
Selector 2-Position, RB2-BJ2 Long 139Stay Put
Selector 2- Position, RB2-BDR2 Standard 129Spring Return
Selector 2-Position, RB2-BJR2 Long 139Stay Put
Selector 3-Position,Stay Put (Centre OFF) RB2-BD3 Standard 129
Selector 3-Position,Stay Put (Centre OFF) RB2-BJ3 Long 139
Selector 3-Position,Spring Return RB2-BDR3 Standard 129(Centre OFF)
Selector 3-Position, RB2-BJR3 Long139Stay Put
Key Selector Key removable2-Position, Stay Put RB2-BG2 in L.H. position
190
Key Selector Key removable2-Position, Stay Put RB2-BG4 in both positions
Key Selector Key removable2-Position, Stay Put RB2-BG02 in R . H. position
Key Selector 2-Position, Key removableSpring Return Stay Put RB2-BG6 in L.H. position
Key Selector 3-Position, Key removableStay Put RB2-BG3 in centre position
190
Key Selector3-Position, Key removableStay Put RB2-BG0 inall positions
190
Key Selector 3-Position, Key removable inStay Put RB2-BG5 L.. H. & R. H. position
190
Key Selector 3-Position, Key removableStay Put RB2-BG9 in L. H. position
Key Selector 3-Position, Key removableStay Put RB2-BG09 in R. H. position
Key Selector 3-Position, Key removableBoth Side Spring Return RB2-BG7 in Centre position
195
Mushroom Head with Key removableKey Stay Put RB2-BS14 in both positions
195 8
ProductPicture
φ30mm
φ40mm
φ60mm
43 20
43 20
48 20
70 8
58
10
52
37 20
57 10
67 10
10
PUSH BUTTON
List Price w.e.f. 19th April 2011 23
Accessories (Metallic Series)For Push Buttons & Pilot Lamps : 22.5mm
Body Assemblies with Contact Blocks, Screw & Captive ClampConnection
How to Order :1. Actuators, switch elements, lens assemblies can be ordered separately or in
combination.2. Basic type designation for actuators is "RB2-B".
Numerical colour code is added as a suffix to indicate the colour of the actuator orlens. Remove "*" and put numerical code as indicated below:
ProductPicture
ProductPicture
IMPORTANT :1) Ordered quantities should be in multiple of standard packing.2) Illuminated Push Buttons & Pilot Lamps
will be supplied with bulb only.3) N in product code stands for Neon Bulb.
Colour Code 1 2 3 4 5 6 7
Colour of Actuator White Black Green Red Yellow Blue —
Colour of Lens White — Green Red Amber Blue Clear
3. Different suffixes are assigned for flush, projecting, selector actuators etc.4. The type designation for contact element is '1' for NO and '2' for NC.5. Basic type designation for legend plates is "RB2-BY". To complete code with
type of inscription please remove "**" and put numerical code as indicatedbelow.
Standard Text Reference Standard Text Reference
Start 2303 Stop 2304Forward 2305 Reverse 2306
Up 2307 Down 2308On 2311 Off 2312
Open 2313 Close 2314Auto 2315 Hand 2316Reset 2323 Inch 2321Slow 2327 Fast 2328
Auto - Hand 2364 Auto - O - Hand 2385
Control Stations (Assembled)
Description ReferenceContact
Unit Std.
TypePrice Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
For Actuators, RB2-BZ101 NO
Push Buttons, RB2-BZ102 NC62 20
Selectors RB2-BZ103 NO+NO
and RB2-BZ104 NC+NC
Key Switches RB2-BZ105 NO+NC
105 10
Control Stations for Customer AssemblyEmpty Enclosure, Plastic
ProductPicture
Yellow 1 RC - 1PY 247
1 RC - 1P 247
Bone Jet 2 RC - 2P 268
Grey Black 3 RC - 3P 305
4 RC - 4P 348
Complete Control Stations Directional/MovementControl FunctionsPlastic, Spring Return
1 RC 2P 222
2 Up-Down RC 2P 222A
2 Flush NO 1 RC 2P 223
Push + 2 Right-Left RC 2P 223A
Button NO 1 Open-Close RC 2P 241
2 Forward - Reverse RC 2P 222B
470
Forward
Stop RC 3P 311
Reverse
3 Flush NO 3 Up
Push + 4 Stop RC 3P 321
Button NC 3 Down
+ Right
NO Stop RC 3P 331
Left
Open
Stop RC 3P 341
Close
1 RC 3P 324
4
2 RC 3P 334
Complete Control Stations - Start and Stop FunctionsPlastic, Spring Return
Description Scheme ColourMarking
ReferenceUnit
on LegendPrice( ` )( ` )( ` )( ` )( ` )
1 Flush NO 3 I RC 1P 102
Push Button START RC 1P 103
1 Flush NC 4 O RC 1P 112
Push Button STOP RC 1P 114
350
Latching NC 4 STOP RC 1PBS542
Push Button RC 1PYBS542400
Mushroom Head NC 4 STOP RC 1PBS142
Key Switch RC 1PYBS142480
2 Flush NO+NC 3 I RC 2P 213470
Push Button 4 O
2 Flush NO+NC 3 START RC 2P 215470
Push Button 4 STOP
ProductPicture
* Empty Enclosure's are available without contact blocks and push buttons andcan be assembled with the accessories / spare parts as per specifiedrequirements.
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
Filament Bulb (BA9S) 130V, 48V, 24V,12V & 6V (2.6W max.) RL1-CF
1920
Neon Bulb (BA9S) 415V, 380V, 220V RL1-CN 19Set of Lens (one inner and one outer)for Pilot Lamp Head RB2-BV00* 21
Lens for LED & Neon Type PilotLamp (w/o inner lens) RB2-BVL00* 19Set of Lens (one inner and one outer)for Illuminating Actuator RB2-BW00* 21 10Lens for Illuminating LED & Neonactuator (w/o inner lens) RB2-BWL00* 21
Silicon Cap suitable for,- Booted Push Button RB2BP00- Push Buttons Flush RC-S
21
- Push Buttons Illuminated RC-L 26Adopter for assembly of
RB2-BZ41 27 10φ30.5 mm in φ22.5 mmLegend Plate with inscription (On, Off,Start, Stop, Slow, Fast, Forward,
RB2-BYN 15 10Reverse, Up, Down, Open, Close, Auto,Auto-o-Hand, Auto - Hand, Reset, Inch.)Body / Carrier with mountingscrews (passivated) for making RB2-B* 19 20different assembliesYellow legend (PVC) φ60mm RB2-PY9330 24 10"Emergency Stop φ90mm RB2-PY8330 28 10
ON /OFF
UnitPrice( ` )( ` )( ` )( ` )( ` )
Description
Base
Numberof Ways
ReferenceTop
ProductPicture
640
PUSH BUTTON
24 List Price w.e.f. 19th April 2011
Complete Control Stations - Start and Stop FunctionsMetal, Spring Return
Control Stations (Assembled)
Description Scheme ColourMarking
ReferenceUnit
on LegendPrice( ` )( ` )( ` )( ` )( ` )
1 Flush NO 3 I RC 1M 102
Push Button START RC 1M 103
1 Flush NC 4 O RC 1M 112
Push Button STOP RC 1M 114
463
Latching NC 4 STOP RC 1MBS542510
Push Button
Mushroom Head NC 4 STOP RC 1MBS142595
Key Switch
2 Flush NO+NC 3 I RC 2M 213
Push Button 4 O
2 Flush NO+NC 3 START RC 2M 215585
Push Button 4 STOP
ProductPicture
* Empty Enclosure's are available without contact blocks and push buttons andcan be assembled with the accessories / spare parts as per specifiedrequirements.
Operating Head for Control StationsFor Customer assembly
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
Flush Push Button RP2-BA1
Spring Return RP2-BA2
RP2-BA3
RP2-BA4
RP2-BA5
RP2-BA6
RP2-BA334
RP2-BA335
Projecting Push Button RP2-BL1
RP2-BL2
RP2-BL3
RP2-BL4
RP2-BL5
RP2-BL6
Mushroom Spring Return RP2-BC2
RP2-BC3
RP2-BC4
RP2-BC5
RP2-BC6
Mushroom Stay Put RP2-BS44 80 10
RP2-BS54 90 08
RP2-BS64 120 05
ProductPicture
φ30mm
φ40mm
φ60mm
Operating Heads for Control StationsWithout Contact Block and Carrier
Description Reference Operating Unit Std.Handle Price Pkg.
( ` )( ` )( ` )( ` )( ` ) (No's)
Selector 2-Position,RP2-BD2 Standard 129Stay Put
Selector 2- Position,RP2-BDR2 Standard 129Spring Return
Selector 3-Position,Stay Put (Centre OFF)
RP2-BD3 Standard 129
Selector 3-Position,Spring Return RP2-BDR3 Standard 129(Centre OFF)
Key Selector Key removable2-Position, Stay Put RP2-BG2 in L.H. position 175
Key Selector Key removable2-Position, Stay Put RP2-BG4 in both positions
Key Selector Key removable2-Position, Stay Put RP2-BG02 in R . H. position
Key Selector 2-Position, Key removableSpring Return Stay Put RP2-BG6 in L.H. position
Key Selector 3-Position, Key removableStay Put RP2-BG3 in centre position
185
Key Selector3-Position, Key removableStay Put RP2-BG0 inall positions
195
Key Selector 3-Position, Key removable inStay Put RP2-BG5 L.. H. & R. H. position
195
Key Selector 3-Position, Key removableStay Put RP2-BG9 in L. H. position
Key Selector 3-Position, Key removableStay Put RP2-BG09 in R. H. position
Key Selector 3-Position, Key removableBoth Side Spring Return RP2-BG7 in Centre position
190
Mushroom Head with Key removableKey Stay Put RP2-BS14 in both positions
185 8
ProductPicture
Plastic Operating Heads without contact Block use with RC.P &RC.M enclosures - IP65
Control Stations for Customer AssemblyEmpty Enclosure, Metal
Complete Control Stations Directional/Movement ControlFunctions Metal, Spring Return
1 RC 2M 222
2 Up - Down RC 2M 222A
2 Flush NO 1 RC 2M 223
Push + 2 Right -Left RC 2M 223A
Button NO 1 Open-Close RC 2M 241
2 Forward-Reverse RC 2M 222B
Forward
Stop RC 3M 311
Reverse
3 Flush NO 3 Up
Push + 4 Stop RC 3M 321
Button NC 3 Down
+ Right
NO Stop RC 3M 331
Left
Open
Stop RC 3M 341
Close
1 RC 3M 324
4
2 RC 3M 334
ProductPicture
1 RC - 1M 370
Smoke Dark 2 RC - 2M 390
Grey Grey 3 RC - 3M 460
4 RC - 4M* 560
UnitPrice( ` )( ` )( ` )( ` )( ` )
Description
Base
Numberof Ways
ReferenceTop
570
720
42 20
42 20
65 8
10
PUSH BUTTON
List Price w.e.f. 19th April 2011 25
Metallic Operating Heads without contact Blockfor RC.P & RC.M enclosures - IP65
Flush Push Button RM2-BA1
Spring Return RM2-BA2
RM2-BA3
RM2-BA4
RM2-BA5
RM2-BA6
RM2-BA334
RM2-BA335
Projecting Push Button RM2-BL1
RM2-BL2
RM2-BL3
RM2-BL4
RM2-BL5
RM2-BL6
Mushroom Spring Return RM2-BC2
RM2-BC3
RM2-BC4
RM2-BC5
RM2-BC6
Mushroom Stay Put RM2-BS44 92 10
RM2-BS54 98 08
RM2-BS64 120 05
Mushroom Push-Pull Type RM2-BT44 98 08
φ30mm
φ40mm
φ60mm
Operating Heads for Control StationsWithout Contact Block and Carrier
Selector 2-Position, RM2-BD2 Standard129Stay Put
Selector 2- Position, RM2-BDR2 Standard129Spring Return
Selector 3-Position,Stay Put (Centre OFF) RM2-BD3 Standard
129
Selector 3-Position,Spring Return RM2-BDR3 Standard 129(Centre OFF)
Key Selector Key removable2-Position, Stay Put RM2-BG2 in L.H. position
175
Key Selector Key removable2-Position, Stay Put RM2-BG4 in both positions
Key Selector Key removable2-Position, Stay Put RM2-BG02 in R . H. position
Key Selector 2-Position, Key removableSpring Return Stay Put RM2-BG6 in L.H. position
Key Selector 3-Position, Key removableStay Put RM2-BG3 in centre position
Key Selector3-Position, Key removableStay Put RM2-BG0 inall positions
195
Key Selector 3-Position, Key removable inStay Put RM2-BG5 L.. H. & R. H. position
195
Key Selector 3-Position, Key removableStay Put RM2-BG9 in L. H. position
Key Selector 3-Position, Key removableStay Put RM2-BG09 in R. H. position
Key Selector 3-Position, Key removableBoth Side Spring Return RM2-BG7 in Centre position
205
Mushroom Head with Key removableKey Stay Put RM2-BS14 in both positions
185 8
ProductPicture
φ40mm
φ40mm
Contact Blocks - Base MountedFor Control Stations Customer Assembly
* Please specify 'M' if required for Metallic and 'P' if required for Plastic.
Contact Block- RB2BE-101B M/P * NO
Slow Break RB2BE-102B M/P * NC41 50
ProductPicture
Legends (Stickers) are supplied with the followingstandard texts, Metal
Legends (Stickers) are supplied with the following standardtexts, Plastic
Start RP2-BY2303 Stop RP2-BY2304
Forward RP2-BY2305 Reverse RP2-BY2306
Up RP2-BY2307 Down RP2-BY2308
On RP2-BY2311 Off RP2-BY2312
Open RP2-BY2313 Close RP2-BY2314
Auto RP2-BY2315 Hand RP2-BY2316
Reset RP2-BY2323 Inch RP2-BY2321
Slow RP2-BY2327 Fast RP2-BY2328
Power On RP2-BY2326 Emer.Stop RP2-BY2330
Right RP2-BY2309 Left RP2-BY2310
O RP2-BY2146 -- RP2-BY2147
RP2-BY1912 RP2-BY1913
RP2-BY1914 RP2-BY1915
Operating Head for Control StationsFor Customer assembly
GLOBAL CERTIFICATION
Start RM2-BY2303 Stop RM2-BY2304
Forward RM2-BY2305 Reverse RM2-BY2306
Up RM2-BY2307 Down RM2-BY2308
On RM2-BY2311 Off RM2-BY2312
Open RM2-BY2313 Close RM2-BY2314
Auto RM2-BY2315 Hand RM2-BY2316
Reset RM2-BY2323 Inch RM2-BY2321
Slow RM2-BY2327 Fast RM2-BY2328
Power On RM2-BY2326 Emer. Stop RM2-BY2330
Right RM2-BY2309 Left RM2-BY2310
O RM2-BY2146 -- RM2-BY2147
RM2-BY1912 RM2-BY1913
RM2-BY1914 RM2-BY1915
ContactType
ReferenceDescriptionUnitPrice( ` )( ` )( ` )( ` )( ` )
UnitPrice( ` )( ` )( ` )( ` )( ` )
ReferenceStandardText
StandardText
ReferenceUnitPrice( ` )( ` )( ` )( ` )( ` )
UnitPrice( ` )( ` )( ` )( ` )( ` )
ReferenceStandardText
StandardText
ReferenceUnitPrice( ` )( ` )( ` )( ` )( ` )
ProductPicture
ReferenceDescriptionUnitPrice( ` )( ` )( ` )( ` )( ` )
Std.Pkg.
(No's)
ReferenceDescriptionUnitPrice( ` )( ` )( ` )( ` )( ` )
Std.Pkg.
(No's)
OperatingHandle
44 20
46 20
75 8
185 10
5 5
5 5
PUSH BUTTON
Std.Pkg.
Note: Minimum order of #10 each.
Note: Minimum order of #10 each.
26 List Price w.e.f. 19th April 2011
Push Buttons (Plastic Series): 22.5mm
Without Contact Elements
Push Button Actuators with Carrier - Non-Illuminated
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
Flush Spring Return Push Button RCP2-BA1
RCP2-BA2
RCP2-BA3
RCP2-BA4
RCP2-BA5
RCP2-BA6
Projecting Push Button RCP2-BL1
RCP2-BL2
RCP2-BL3
RCP2-BL4
RCP2-BL5
RCP2-BL6
Mushroom Head Push Button, RCP2-BC2
Spring Return RCP2-BC3
RCP2-BC4
RCP2-BC5
RCP2-BC6
Mushroom Head Push
Button Stay Put (press toRCP2-BS54 103 8
lock, turn to release) RCP2-BS64 139 5
Mushroom Head Push Button,Push to Stay & Key to release
RCP2-BS14 198 8
Push Button Stay Put(Press to Lock turn to release
RCP2-BS44 98 10
ProductPicture
LED Type Push Button Actuators - Illuminated Flush
▲ Add Voltage Code, Operating voltage available in 240V AC, 110V & 220V DC
LED Type Push Button Actuators - Illuminated ProjectingType of voltage AC/DC to be specified
▲ Add Voltage Code Operating Voltage available in 240V AC & 220V DC
Projecting Illuminated Actuator, RCP2-BWL137▲
with integral circuit and cluster RCP2-BWL147▲
LED, suitable for operating at RCP2-BWL157▲ 149 10240V, 220V, 110V, 48V,24V &12V
Projecting Illuminated Actuator,with integral circuit and clusterLED, suitable for operating at RCP2-BWL167▲ 355 10240V, 220V, 110V, 48V, 24V,& 12V
Push Button Actuator-Illuminated Projectingwithout Series Resistor
Illuminated Actuator, Flush RCP2-BW116▲
(With BA9 Filament Bulb) RCP2-BW136▲
12V, 24V, 48V, 110V AC / DC RCP2-BW146▲
RCP2-BW156▲
RCP2-BW166▲
RCP2-BW176▲
Illuminated Actuator, Flush RCP2-BWN136▲
(With BA9 Neon Bulb) RCP2-BWN146▲
220V, 380V, 415V AC / DC RCP2-BWN156▲
108 10
Flush Illuminated With Integral RCP2-BWL337▲
Circuit and Clusted Type LED RCP2-BWL347▲
suitable for operationg at 240V RCP2-BWL357▲149 10
220V, 110V, 48V, 24V & 12V
Flush Illuminated With Integral
RCP2-BWL367▲ 247 10Circuit and Clusted Type LEDsuitable for operationg at 240V220V, 110V, 48V, 24V & 12V
φ40mm
φ60mm
▲Add Voltage Code
Push Button Actuators - Illuminated Projectingwith Series Resistor
Illuminated Actuator, Projecting RCP2-BW117▲
(with BA9S Filament Bulb,130V) RCP2-BW137▲
220V AC / DC RCP2-BW147▲
RCP2-BW157▲
RCP2-BW167▲
RCP2-BW177▲
113 10
▲Add Voltage Code
Push Button Actuators - Illuminated Flushwithout Series Resistor
Illuminated Actuator, Flush RCP2-BW316▲
(With BA9 Filament Bulb) RCP2-BW336▲
12V, 24V, 48V, 110V AC / DC RCP2-BW346▲
RCP2-BW356▲
RCP2-BW366▲
RCP2-BW376▲
Illuminated Actuator, Flush RCP2-BWN336▲
(With BA9 Neon Bulb) RCP2-BWN346▲
220V, 380V, 415V AC / DC RCP2-BWN356▲
Illuminated Actuator, Flush RCP2-BW317▲(with BA9S Filament Bulb, 130V) RCP2-BW337▲
220V AC/DCRCP2-BW347▲
RCP2-BW357▲
RCP2-BW367▲
RCP2-BW377▲
Push Button Actuators - Illuminated Flushwith Series Resistor
▲ Add Voltage Code
▲ Add Voltage Code, Operating voltage available in 240V AC, 110V & 220V DC
Colour Code 1 2 3 4 5 6 7
Colour of Actuator White Black Green Red Yellow Blue —
Colour of Lens White — Green Red Amber Blue Clear
Colour Code for Actuator / Lens
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
ProductPicture
Description ReferenceUnit Std.
Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
ProductPicture
φ30mm
44 20
47 20
74 8
113 10
121 10
PUSH BUTTON
List Price w.e.f. 19th April 2011 27
Selector Actuators (Plastic Series): 22.5mmWithout Contact Elements
Key Actuators with Carrier
2-Position Key Switch, Keyremovable in unactuated position RCP2-BG2
2-Position Key Switch, Keyremovable in both position RCP2-BG4
2-Position Key Switch, Keyremovable in 'Right Hand' position RCP2-BG02
2-Position (Spring Return) Key Switch, Key RCP2-BG6removable in 'Left Hand' position
3-Position Key Switch, Keyremovable in centre 'OFF' position RCP2-BG3
3-Position Key Switch, Keyremovable in all position RCP2-BG0
3-Position Key Switch, Key removablein 'Left Hand & Right Hand ' position RCP2-BG5
3-Position Key Switch, Key removablein 'Left Hand' position RCP2-BG9
3-Position Key Switch, Key removablein 'Right Hand' position RCP2-BG7
Selector Switch Actuators with Carrier
2-Position Selector Switch (stay put) RCP2-BD2
3-Position Selector Switch,centre 'OFF' (stay put) RCP2-BD3
139
2-Position Selector Switch withextra long knob (stay put) RCP2-BJ2
3-Position Selector Switch, with extra
long knob centre 'OFF' (stay put) RCP2-BJ3
144
2-Position Selector Switch
(Spring Return) RCP2-BDR2
3-Position Selector Switch
(Spring Return) RCP2-BDR3
159
2-Position Selector Switch
extra long knob (Spring Return) RCP2-BJR23-Position Selector Switch
extra long knob (Spring Return) RCP2-BJR3
164
Description ReferenceUnit Std.Price Pkg.( ` )( ` )( ` )( ` )( ` ) (No's)
ProductPicture
▲Add Voltage Code, Operating voltage available in 240V AC & 220V DC
▲ Add Voltage Code
Pilot Lamps with Transformer
Pilot Lamp (with BA9S Filament RCP2-BV41▲
Bulb) for Input Voltage:240V AC RCP2-BV43▲
and output Voltage: 6VAC RCP2-BV44▲
RCP2-BV45▲
RCP2-BV46▲
RCP2-BV47▲
Pilot Lamp (with BA9S Filament RCP2-BV31▲
Bulb) for input Voltage:110V AC RCP2-BV33▲
and output Voltage: 6V AC RCP2-BV34▲
RCP2-BV35▲
RCP2-BV36▲
RCP2-BV37▲
Pilot Light with integral circuit RCP2-BVL73▲
& cluster LED, suitable for RCP2-BVL74▲
operating at 240V , 220V RCP2-BVL75▲
110V, 48V, 24V & 12V RCP2-BVL77▲
128 10
Pilot Light with integral circuit
RCP2-BVL76▲ 260 10
& cluster LED, suitable foroperating at 240V , 220V
110V, 48V, 24V & 12V
Pilot Lamps with Series Resistor
Pilot Lamp (with BA9S Filament RCP2-BV71▲
Bulb 130V) 220V AC / DC RCP2-BV73▲
RCP2-BV74▲
RCP2-BV75▲
RCP2-BV76▲
RCP2-BV77▲▲Add Voltage Code
Pilot Lamps with Series Resistor & Diode
Pilot Lamp (with BA9S Filament RCP2-BVD71▲
Bulb 130V) 240V AC RCP2-BVD73▲
RCP2-BVD74▲
RCP2-BVD75▲
RCP2-BVD76▲
RCP2-BVD77▲
▲Add Voltage Code
Add Voltage Code, Operating voltage available in 240V AC, 110V & 220V DC
Note: Please mention supply voltage of Pilot Lamps, Pilot Light BodyAssemblies and Illuminated Push Buttons with product reference while ordering.
Voltage Code for Pilot Lamps
Voltage Code 12V 24V 48V 110V 220V 240V 380V 415V
AC JA BA EA FA MA UA QA NA
DC JD BD ED FD MD - Q D ND
ProductPicture
LED Type Pilot Lamp Type of voltage AC / DC to be specified
Description ReferenceUnitPrice( ` )( ` )( ` )( ` )( ` )
Std.Pkg.
(No's)
10
195
10
200
245 8
98 10
103 10
Reset Extended ActuatorPushbutton - Round Type RCB2AL8R 41
10Reset Extended ActuatorPushbutton - Hex Type RCB2AL8H 41
Plastic Adopter for 30 mmhole to 22.5 mm. RP2-BZ41M 15
20Metal Adopter for 30 mmhole to 22.5 mm. RB2-BZ41M 15
Recess (Guarded) RP2-BA16Push button - Plastic RP2-BA26
RP2-BA36 10RP2-BA46 RP2-BA56 RP2-BA66
Recess (Guarded) RB2-BA16 Push button - Metal RB2-BA26
RB2-BA36 10RB2-BA46 RB2-BA56 RB2-BA66
Intermittent Sounding Flashing RB2-KS* 113Buzzer 15 ~ 20 mA, sound level80 dB.24V, 48V, 110V AC/DC 10240V AC (* Add Voltage code)
Push Buttons Extended Range
36
41
PUSH BUTTON
Maximum Retail PricePower Distribution Power Control Final Power Distribution
General Terms & Conditions
n
n
POR - Price on request
Products have been classified as Stockable & Non Stockable
items. Non Stockable items has been marked as
MCCBs
Switch Disconnector FusesUnits
Switch Disconnectors
Changeover Switches
HRC Fuses
Power Capacitors
Power
Distribution Components
MRP w.e.f. 19th April 2011 33
Range 5A - 1200A, 600V
5kA 5,10,15,20,30,40,50 CS1A2* 1700 CS1A3* 1870 - -
10kA5,10,15,20,30,40,50,60 CS2A2* 1720 CS2A3* 1900 CS2A4* 2800
75,100 CS2A2* 1740 CS2A3* 1960 CS2A4* 2870
18kA
125 CS3A2* 4120 CS3A3* 4750 CS3A4* 7080
150 CS3A2* 4420 CS3A3* 5300 CS3A4* 8550
175,200 CS3A2* 6100 CS3A3* 7100 CS3A4* 9000
225 CS3A2* 8600 CS3A3* 11000 CS3A4* 12000
25kA
15,20,30,40,50,60 CS2B2* 3500 CS2B3* 4300 CS2B4* 6000
75,100 CS2B2* 3520 CS2B3* 4400 CS2B4* 6250
125 CS3B2* 5550 CS3B3* 6250 CS3B4* 8300
150 CS3B2* 6000 CS3B3* 8200 CS3B4* 9650
175,200 CS3B2* 8900 CS3B3* 9700 CS3B4* 11750
225 CS3B2* 10300 CS3B3* 11600 CS3B4* 12500
250,300 - - CS4A3* 13000 CS4A4* 14700
350,400 - - CS4A3* 19000 CS4A4* 23500
15,20,30,40,50,60 - - CS2C3* 6000 CS2C4* 7000
75,100 - - CS2C3* 6400 CS2C4* 7400
125 - - CS3C3* 7100 CS3C4* 9000
150 - - CS3C3* 9100 CS3C4* 10700
175,200 - - CS3C3* 10900 CS3C4* 13700
225 - - CS3C3* 17500 CS3C4* 19600
250,300 - - CS4B3* 19000 CS4B4* 22200
350,400 - - CS4B3* 20500 CS4B4* 26000
500,630 - - CS5A3* 25200 CS5A4* 30000
700,800 - - CS5A3* 30500 CS5A4* 35700
250,300 - - CS4C3* 19100 CS4C4* 21700
350,400 - - CS4C3* 22500 CS4C4* 27200
500,630 - - CS5B3* 27000 CS5B4* 31800
700,800 - - CS5B3* 33000 CS5B4* 41000
125,150,175,200 - - CS3D3* POR CS3D4* POR
1000 - - CS6B3* 71000 CS6B4* 80500
1200 - - CS7B3* 78000 CS7B4* 100000
250, 300 - - CS4D3* 23000 CS4D4* 31000
350, 400 - - CS4D3* 26000 CS4D4* 32000
500, 630 - - CS5D3* 31000 CS5D4* 37000
700, 800 - - CS5D3* 45000 CS5D4* 53000
WiNbreakMoulded Case Circuit Breakers(Standard packing includes extended terminals, insulating phase barrier and Hardware.)
Notes : 1. MCCB of 400A Frame & 800A Frame has variable thermal setting with use of rating plug refer Page no. 34 for options of the rating plug.
2. While Ordering, Replace "*" by Rated Current required.
3. Extended terminals are not included.
4. 80A MCCB is also available upto 18kA
5. For technical details please refer product Catalogue
6. For availability & prices please contact nearest branch office.7. Price for 1200A 3P / 4P MCCB available on request.
4 PoleReference
3 PoleReference
MRP( ` )( ` )( ` )( ` )( ` )
2 PoleReference
Rated Current (Amps)Breakingcapacity
MCCBMCCBMCCBMCCBMCCB
35kA
50kA
65kA
85kA
N o n S t o c k a b l e i t e m
MRP( ` )( ` )( ` )( ` )( ` )
MRP( ` )( ` )( ` )( ` )( ` )
• Positive isolation • Trip free mechanism
MRP w.e.f. 19th April 201134
WiNbreakMoulded Case Circuit BreakersPlug-in MCCB (Available till stock lasts)
For line/Load Side
Notes :1. With each relay, suitable Shunt trip of 220V AC only to be ordered seperately.2. Last figure denotes CT Ratio and thus order accordingly.
15~100 EFR100-AF-100 3800
125~225EFR225-AF-150 4140
EFR225-AF-200 4140
250~400EFR400-AF-250 4530
EFR400-AF-400 4530
600~800EFR800-AF-600 5240
EFR800-AF-800 5240
1000~1200EFR1200-AF-1000 8650
EFR1200-AF-1200 8650
Terminal Covers
Enclosure for MCCBs
Suitable for use on MCCBs Reference MRP (`)(`)(`)(`)(`)
CS2A3 (10kA) / CS2B3 (25kA) / CS2C3 (35kA) ENCL100AF 1550
Mechanical Interlock (Used to prevent mechanically closing together)
CS4A3,CS4B3,CS4C3,CS4D3 MI-43S 2920
CS4A4,CS4B4,CS4C4,CS4D4 MI-44S 3640
CS5A3,CS5B3,CS5C3,CS5D3 MI-83S 3640
CS5A4,CS5B4,CS5C4,CS5D4 MI-84S 4300
CS1A2,CS2A2,CS2A4 TBS-12B 180
CS1A3,CS2A3 TBS-13B 240
CS2B2 TBS-22B 290
CS2B3,CS2C3 TBS-23B 360
CS2B4,CS2C4 TBS-24B 420
CS3A2/A3,CS3B2/B3,CS3C3 TBS-33B 420
CS3A4,CS3B4,CS3C4 TBS-34B 530
CS4A3/A4,CS4B3/B4,CS4C3/C4,CS4D3/D4 T1-43A 610
CS5A3/A4,CS5B3/B4,CS5C3/C4,CS5D3/D4 T1-63A 700
ACCESSORIES for MCCBsRating Plug
250 CS4 RP250A
300 CS4 RP300A530
350 CS4 RP350A
400 CS4 RP400A580
500 CS5 RP500A
600 CS5 RP600A690
700 CS5 RP700A
800 CS5 RP800A830
Note: While Ordering, Place order for both MCCB and suitable Plug-in base mentioned above.
5kA 5,10,15,20,30,40,50 CS1A3P PB-A3-FR
10kA 15,20,30,40,50,60,75,100 CS2A3P PB-A3-FR
25kA 15,20,30,40,50,60,75,100 CS2B3P PB-C3-FR
35kA 15,20,30,40,50,60,75,100 CS2C3P PB-C3-FR
18kA 125,150,175,200,225 CS3A3P PB-D3-FR
25kA 125,150,175,200,225 CS3B3P PB-D3-FR
35kA 125,150,175,200,225 CS3C3P PB-D3-FR
25kA 250A,300A,350A & 400A CS4A3P POR PB-I3-FR POR
35kA 250A,300A,350A & 400A CS4B3P PB-I3-FR
85kA 250A,300A,350A & 400A CS4D3P PB-I3-FR
35kA 500A & 630A CS5A3P PB-J3-FR
50kA 500A & 630A CS5B3P PB-J3-FR
85kA 500A & 630A CS5D3P PB-J3-FR
35kA 700A & 800A CS5A3P PB-J3-FR
50kA 700A & 800A CS5B3P PB-J3-FR
85kA 700A & 800A CS5D3P PB-J3-FR
Plug-in BaseReference
3 PoleReference
Rated Current (Amps)Breaking capacity(Icu) at 415V AC
MRP( ` )( ` )( ` )( ` )( ` )
Plug Rating(Amps)
ReferenceSuitable for MCCB
Suitable for use on MCCBsReference
ReferenceFor MCCB rating
(Amps)
Suitable for use onMCCBs Reference
Applied between two MCCBs
Earth fault Relay (with NCT's)
MCCBMCCBMCCBMCCBMCCB
N o n S t o c k a b l e i t e m
MRP( ` )( ` )( ` )( ` )( ` )
MRP( ` )( ` )( ` )( ` )( ` )
MRP (`)(`)(`)(`)(`)MRP (`)(`)(`)(`)(`)
MRP (`)(`)(`)(`)(`)
MRP w.e.f. 19th April 2011 35
WiNbreakACCESSORIES for MCCBs
CS1A3,CS2A3/CS2A4 ST -A ( . .V ) 750 UVT -A ( . . V ) 1015 ASW-A(R)* 750 ALSW-A(R) 750 D - 3 5 S 700 E-35S 1850
CS1A2,CS2A2 ST -A ( . .V ) 750 UVT -A ( . . V ) 1015 ASW-A(T)* 750 ALSW-A(T) 750 D - 3 5 S 700 E-35S 1850
CS2B3/B4,CS2C3/C4 S T - B ( . . V ) 750 UV T - B ( . . V ) 1200 ASW-B(R)* 950 ALSW-B(R) 950 D - 4 5 S 750 E-45S 2100
CS2B2 S T - B ( . . V ) 750 UV T - B ( . . V ) 1200 ASW-B(T)* 950 ALSW-B (T) 950 D - 4 5 S 750 E-45S 2100
CS3A3/A4,CS3B3/B4,CS3C3/C4 S T -C ( . . V ) 750 UV T -C ( . . V ) 1200 ASW-C(R)* 950 ALSW-C (R) 950 D - 5 5 S 830 E-55S 2350
CS3A2,CS3B2 S T -C ( . . V ) 750 UV T -C ( . . V ) 1200 ASW-C(T)* 950 ALSW-C(T) 950 D - 5 5 S 830 NA -
CS1D3,CS2D3 ST -4A ( . .V ) 1250 UVT -4A ( . . V ) 1550 ASW-4A(R)* 1150 ALSW-4A(R) 1150 N - 5 5 1050 NA -
CS1D4,CS2D4 S T -4B ( . . V ) 1250 UV T -4B ( . . V ) 1550 ASW-4A(T)* 1150 ALSW-4A(T) 1150 N - 5 5 1050 NA -
CS3D3 ST -5A ( . .V ) 1410 UVT -5A ( . . V ) 1750 ASW-5A(R)* 1150 ALSW-5A(R) 1150 N - 6 0 1050 NA -
CS3D4 S T -5B ( . . V ) 1410 UV T -5B ( . . V ) 1750 ASW-5A(T)* 1150 ALSW-5A(T) 1150 N - 6 0 1050 NA -
CS4A3/A4,CS4B3/B4, S T -6A ( . .V ) 1480 UVT -6A ( . .. V ) 1800 ASW-6A 1150 ALSW-6A 1150 N - 7 0 S 1580 E-70U 2550
CS4C3/C4,CS4D3/D4, S T -6A ( . .V ) 1480 UVT -6A ( . .. V ) 1800 ASW-6A 1150 ALSW-6A 1150 N - 7 0 S 1580 E-70U 2550
CS5A3/A4,CS5B3/B4, S T -6A ( . .V ) 1480 UVT -6A ( . .. V ) 1800 ASW-6A 1150 ALSW-6A 1150 N - 7 0 M 1690 E-80U 2850
CS5C3/C4,CS5D3/D4 ST -6A ( . .V ) 1480 UVT -6A ( . .. V ) 1800 ASW-6A 1150 ALSW-6A 1150 N - 7 0 M 1690 E-80U 2850
CS6B3/B4,CS7B3/B4 S T -7A ( . .V ) 5700 NA - ASW-7A 3000 ALSW-7A 3000 NA - - -
CS7B3E ST -7E ( . .V ) 5700 NA - ASW-7A 3000 ALSW-7A 3000 NA - - -
Shunt Trip Under Voltage Trip Auxiliary Switch Extended Rotary Handle
Suitable for use on MCCBs
Alarm Switch Direct Rotary Handle
Electrical Auxiliaries Shunt & UVT are mounted on Right-hand Seat (T)For correct selection of ASW & ALSW, refer Picture CS1
*Please read R as MCCB left hand side position & T as right hand position
*Please read R as MCCB left hand side position & T as right hand position
Please refer above auxiliary selection for 3 & 4 Pole WiNbreak MCCB Only
Notes : 1. While Ordering Replace " * " by Rated Current required.2. Shunt Trip Coil & UVT available in 24, 48V,110V,220V & •415V AC/DC
(Replace … by required Voltage). 220V & 415V are standard stock items.UVT - 6A not available in 24V AC/DC.(• not available for 1000A & 1200A MCCBs)
3. Single block for one Aux. Sw +one Alarm Switch available upto 225AF.Order the same as follows:- Replace ASW-A+ALSW-A to XL-A(T) : ` 1650 (Unit Price)- Replace ASW-B+ALSW-B to XL-B(T) : ` 2180 (Unit Price)- Replace ASW-C+ALSW-C to XL-C(T) : ̀ 2180 (Unit Price)
4. Rotary handle for Horizontal (Left&Right) mounting also available onrequest.
5. Rotary Handle for 50AF & 100AF, 2Pole not available.
Extended rotary handle (metallic) is also available.
Picture CS1
Right-handSeat (T*)
Left-handSeat (R*)
Reference ReferenceMRP( ` )( ` )( ` )( ` )( ` )
MRP( ` )( ` )( ` )( ` )( ` )
ReferenceMRP( ` )( ` )( ` )( ` )( ` )
ReferenceMRP( ` )( ` )( ` )( ` )( ` )
ReferenceMRP( ` )( ` )( ` )( ` )( ` )
ReferenceMRP( ` )( ` )( ` )( ` )( ` )
MCCBMCCBMCCBMCCBMCCB
MRP w.e.f. 19th April 201136
FMU (Thermal Magnetic) Release Adjustable Overload 80-100% Fixed short circuit
50 16,20,25,32,40,50,63,80,100 CD100NFMU*3P 7600 CD100NFMU*4P 11100
50 100 & 125 CS160NFMU*3P 10800 CS160NFMU*4P 15000
50 160 CS160NFMU*3P 13400 CS160NFMU*4P 18500
50 125,160 & 200 CS250NFMU*3P 17600 CS250NFMU*4P 23000
50 250 CS250NFMU*3P 20200 CS250NFMU*4P 26200
65 300 & 400 CS400NFMU*3P 23100 CS400NFMU*4P 32000
65 500 & 630 CS630NFMU*3P 27200 CS630NFMU*4P 35000
65 800 CS800NFMU*3P 38850 CS800NFMU*4P 56500
Moulded Case Circuit Breakers
50 125 CS160NATU*3P 11100 CS160NATU*4P 15600
50 160 CS160NATU*3P 13800 CS160NATU*4P 18700
50 125,160 & 200 CS250NATU*3P 18000 CS250NATU*4P 23700
50 250 CS250NATU*3P 21000 CS250NATU*4P 26700
65 300 & 400 CS400NATU*3P 24000 CS400NATU*4P 32600
65 500 & 630 CS630NATU*3P 28500 CS630NATU*4P 36500
65 800 CS800NATU*3P 41000 CS800NATU* 4P 57800
ATU (Thermal Magnetic) Release Adjustable Overload 80 - 100% Adjustable Short circuit 5 - 10 In
4 pole MCCBs are with Neutral protectionagainst overload and shortcircuit
ETS (Microprocessor based) Release•
Adjustable Overload 40 - 100% Adjustable shortcircuit 1.5 - 10 In
50 40, 80, 160 CS160NETS*3P 21000
50 40, 80, 160, 250 CS250NETS*3P 24200
65 160, 250, 400 CS400NETS*3P 26500
65 160, 250, 400, 630 CS630NETS*3P 32000
65 630, 800 CS800NETS*3P 45000
Note : Replace " * " with required current range
4 pole MCCBs are with Neutral protectionagainst overload and shortcircuit
WiNbreak2
BreakingcapacityIcu = Ics
3 Pole#Reference
MRP (`)(`)(`)(`)(`)Rated Current (Amps)
BreakingcapacityIcu = Ics
Rated Current(Amps)
3 Pole Reference MRP (`)(`)(`)(`)(`)4 Pole Reference MRP (`)(`)(`)(`)(`)
BreakingcapacityIcu = Ics
Rated Current(Amps)
3 Pole Reference MRP (`)(`)(`)(`)(`)
4 Pole Reference MRP (`)(`)(`)(`)(`)
MCCBMCCBMCCBMCCBMCCB
MCCB with microprocessor release having OL, SC, EF,Ammeter, ZSI & RS485 port is also available. For pricescontact nearest branch office.
• Microprocessor release with in-built earth fault protection is also available
Extended terminals are not included for MCCBs upto 63A
Exeptional current limiting device with double break contacts (Ics=Icu=100%)
• Positive isolation • Double Break • Trip free mechanism • 100% Neutral Protection in 4 Pole • Intelligent Trip Unit
MRP w.e.f. 19th April 2011 37
Notes : 1) The above accessories are common to entire WiNbreak2MCCBs. * Specify Coil Voltage (12V, 24V, 48V, 110V, 220V AC/DC & 415AC) 220V & 415V are stock item.
2) WiNbreak2 MCCBs are available up to Icu=Ics=150kA for entirerange for higher short circuit level, Price avialable on request.
3.) # 4 pole MCCB with microprocessor release is also available.For prices please contact nearest branch office.
Suitable for Control MRPMCCB Type Voltage ((((( `̀̀̀̀ )))))
CD100 MOP1*100V-200V AC 24V DC
14890100V & 220V DC
CS160, 250 MOP2*100V-110V AC, 230V AC
1974024V DC & 220V DC
CS400, 630 MOP3*100V-110V AC, 230V AC
3109024V DC & 220V DC
CS800 MOP4* 100V-110V AC, 230V AC 3672024V DC & 220V DC
Padlocking Device for WiNbreak2 MCCB
Suitable for MCCB Type Reference MRP (`)(`)(`)(`)(`)
CD 100 / 160 PHL 1 1100CS 160 / 250 PHL 2 1220CS 400 / 630 PHL 3 1960CS 800 PHL 4 2210CD 100 / 160 PL 1 640CS 160 / 250 PL 2 830CS 400 / 630 PL 3 1000CS 800 PL 4 1050
PHL - Fixed Type PL - Removable Type
Motor Operator for WiNbreak2 MCCBs
Motor Type
MCCBMCCBMCCBMCCBMCCB
Aux. Switch AX-T 1000
Alarm Switch AL-T 1000
Fault Alarm Switch FAL-T 1000
Shunt trip coil ST-T* 2320
UVT coil UVT-T* 3140
Internal Accessories for WiNbreak2 MCCBs
Description MRP (`)(`)(`)(`)(`)Reference
Plug-in Base For WiNbreak2 MCCB
Suitable for MCCB Type Reference MRP (`)(`)(`)(`)(`)
CD 100 / 160 3P PB 13 12570
CS 160 / 250 3P PB 23 15600
CS 400 / 630 3P PB 33 25030CS 800 3P PB 43 62620
Direct Rotary Handle with Keylock for WiNbreak2 MCCB
Suitable for MCCB Type Reference MRP (`)(`)(`)(`)(`)
CD 100 DHK1-S 3570
CS 160 & 250 DHK2-S 3760
CS 400 & 630 DHK3-S 3940CS 800 DHK4-S 4100
CD100 DH1-S 1260 EH1-S 1890
CS160 & 250 DH2-S 1370 EH2-S 2260
CS 400 & 630 DH3-S 2680 EH3-S 3520
CS 800 DH4-S 3200 EH4-S 4150
Suitable forMCCB Type
Direct Extended
Rotary Handle for WiNbreak2 MCCBs
MRP (`)(`)(`)(`)(`)Reference MRP (`)(`)(`)(`)(`)Reference
CD100 MIT13 6200 MIT14 6510
CS160 & 250 MIT23 7560 MIT24 7820
CS 400 & 630 MIT33 8030 MIT34 8240
CS 800 MIT43 8510 MIT44 8770
Suitable forMCCB Type
3 Pole 4 Pole
Mechanical Interlock Device for WiNbreak2 MCCBs
MRP (`)(`)(`)(`)(`)Reference MRP (`)(`)(`)(`)(`)Reference
N o n S t o c k a b l e i t e m
WiNbreak 2ACCESSORIES for MCCBs
MRP w.e.f. 19th April 201138
ACE 2Moulded Case Circuit Breakers
16,20,25,32,40,50,63 CSCN125TM*3P 6200 CSCN125TM*4P 7650
80,100 CSCN125TM*3P 6400 CSCN125TM*4P 8000
125 CSCN125TM*3P 7350 CSCN125TM*4P 8800
160, 180 CSCN250TM*3P 9550 CSCN250TM*4P 11600
200 CSCN250TM*3P 11000 CSCN250TM*4P 14500
250 CSCN250TM*3P 13200 CSCN250TM*4P 18200
100 CSCS125TM*3P CSCS125TM*4P
125 CSCS250TM*3P CSCS125TM*4P
160 CSCS250TM*3P CSCS250TM*4P
200 CSCS250TM*3P CSCS250TM*4P
250 CSCS250TM*3P CSCS250TM*4P
Thermal Magnetic Release (Adjustable Overload & Short Circuit setting)Breaking Capacity
Ics=Icuat 415V AC (kA)
Rated Current (Amps) 3 Pole Reference MRP (`)(`)(`)(`)(`) 4 Pole Reference MRP (`)(`)(`)(`)(`)
36kA
40,100,125 CSCN125EM*3P 9600 CSCN125EM*4P 11800
160 CSCN250EM*3P 12000 CSCN250EM*4P 13800
200 CSCN250EM*3P 15200 CSCN250EM*4P 16800
250 CSCN250EM*3P 17600 CSCN250EM*4P 19500
40,100 CSCS125EM*3P CSCS125EM*4P
125 CSCS125EM*3P CSCS125EM*4P
160 CSCS250EM*3P CSCS250EM*4P
200 CSCS250EM*3P CSCS250EM*4P
250 CSCS250EM*3P CSCS250EM*4P
315, 350, 400 CSCS400EM*3P CSCS400EM*4P
500, 630 CSCS630EM*3P CSCS630EM*4P
700, 800 CSCS800EM*3P CSCS800EM*4P
1000 CSCS1250EM*3P CSCS1250EM*4P
1250 CSCS1250EM*3P CSCS1250EM*4P
40,100 CSCH125EM*3P CSCH125EM*4P
125 CSCH125EM*3P CSCH125EM*4P
160 CSCH250EM*3P CSCH250EM*4P
200 CSCH250EM*3P CSCH250EM*4P
250 CSCH250EM*3P CSCH250EM*4P
315, 350, 400 CSCH400EM*3P CSCH400EM*4P
500, 630 CSCH630EM*3P CSCH630EM*4P
700, 800 CSCH800EM*3P CSCH800EM*4P
1000 CSCH1250EM*3P CSCH1250EM*4P
1250 CSCH1250EM*3P CSCH1250EM*4P
Microprocessor ReleaseLSIN - Adjustable Overload, Short Circuit, Instantaneous and Neutral Protection
Rated Current (Amps) 3 Pole Reference MRP (`)(`)(`)(`)(`) 4 Pole Reference MRP (`)(`)(`)(`)(`)
36kA
50kA
70kA
Extended terminals are not included.
POR POR
POR POR
Breaking CapacityIcs=Icu
at 415V AC (kA)
N o n S t o c k a b l e i t e m
50kA
POR
POR
• Positive isolation • Double Break • Trip free mechanism
• Adjustable Overload
• Fixed Short Circuit
• Adjustable Overload
• Adjustable Short Circuit
• Adjustable Overload
• Adjustable Short Circuit
• Adjustable Overload
• Fixed Short CircuitPOR
POR
MRP w.e.f. 19th April 2011 39
Internal Accessories
Descr ipt ionDescr ipt ionDescr ipt ionDescr ipt ionDescr ipt ion F rameF rameF rameF rameF rameVol tageVol tageVol tageVol tageVol tage
M R PM R PM R PM R PM R P220 V AC 380/415 V AC 24 V DC 110 V DC ( ` )( ` )( ` )( ` )( ` )
CSCN125TM STC92 STC95 STC98 -- 1550
CSC*125EM
CSC*250EM
CSCN250TM STC93 STC96 STC99 -- 1750
CSC*400EM
CSC*630EM
CSC*800EM STC94 STC97 STC00 STC01 POR
CSC*1250EM
CSCN125TM UVTC02 UVTC05 -- -- 2350
CSC*125EM
CSC*250EM
CSCN250TM UVTC03 UVTC06 -- -- 2550
CSC*400EM
CSC*630EM
CSC*800EMUVTC04 UVTC07 -- -- POR
CSC*1250EM
Shunt Release
U/V Release
Auxiliary Contact(Left) AXC-L
Auxiliary Contact(Middle) AXC-M 825
Auxiliary Contact(right) AXC-R
Alarm Contact ALC 925
Aux/Alarm Contacts
Description MRP (`)(`)(`)(`)(`)Reference
CSCN125TM MOPC-88 240AC/220VDC
CSC*125/250EMMOPC-89 240AC/220VDC
CSCN250TM
CSC*400/630EM MOPC-90 230VAC/220VDC
CSC*800/1250EM MOPC-91 AC230V400V
Motor Operator
Suitable for MCCB Typ MRP (`)(`)(`)(`)(`)ReferenceReference
ACE 2ACCESSORIES for MCCBs
CSCN125TM EC-55 EC-19 1650
CSC*125EM
CSC*250EM EC-56 EC-20 2050
CSCN250TM
CSC*400EM
CSC*630EMEC-57 EC-21
CSC*800EM
CSC*1250EMEC-58 EC-58
Extended Rotary Handle
Description MRP (`)(`)(`)(`)(`)4 Pole3 Pole
POR
N o n S t o c k a b l e i t e m
POR
MRP w.e.f. 19th April 201140
24~32 CSZ2B3 32
32~40 CSZ2B3 40
40~50 CSZ2B3 50
50~63 CSZ2B3 63
63~80 CSZ2B3 80
80~100 CSZ2B3 100
100~125 CSZ2B3 125
125~160 CSZ3B3 160
160~200 CSZ3B3 200
200~250 CSZ3B3 250
Breaking capacity Ics=75% of Icu
Breaking CapacityIcu at 415V AC
Rated Current (Amps) 3 Pole Reference MRP (`)(`)(`)(`)(`) 4 Pole Reference MRP (`)(`)(`)(`)(`)
25kA
CSZ2B4 32
CSZ2B4 40
CSZ2B4 50
CSZ2B4 63
CSZ2B4 80
CSZ2B4 100
CSZ2B4 125
CSZ3B4 160
CSZ3B4 200
CSZ3B4 250
ACEMoulded Case Circuit Breakers
25kA
POR POR
24~32 CSZ2H3 32
32~40 CSZ2H3 40
40~50 CSZ2H3 50
50~63 CSZ2H3 63
63~80 CSZ2H3 80
80~100 CSZ2H3 100
100~125 CSZ2H3 125
125~160 CSZ3H3 160
160~200 CSZ3H3 200
200~250 CSZ3H3 250
Breaking capacity Ics=100% of Icu
Breaking CapacityIcu at 415V AC
Rated Current (Amps) 3 Pole Reference MRP (`)(`)(`)(`)(`) 4 Pole Reference MRP (`)(`)(`)(`)(`)
25kA
CSZ2H4 32
CSZ2H4 40
CSZ2H4 50
CSZ2H4 63
CSZ2H4 80
CSZ2H4 100
CSZ2H4 125
CSZ3H4 160
CSZ3H4 200
CSZ3H4 250
25kA
POR POR
Extentended terminals not included - Please contact nearest Branch Office for prices
Aux. Switch for MCCB upto 125 AF AXZ2
Aux. Switch for MCCB upto 250 AF AXZ3
Alarm Switch for MCCB upto 125 AF ALZ2
Alarm Switch for MCCB upto 250 AF ALZ3
Extended Rotary Handle for MCCB upto 125 AF DHZ2
Extended Rotary Handle for MCCB upto 250 AF DHZ3
UVZ2-230V AC
UVT Release-125 AF (230VAC, 400VAC, 24VDC) UVZ2-400V AC
UVZ2-24V DC
UVZ3-230V AC
UVT Release 250 AF (230VAC, 400VAC, 24VDC) UVZ3-400V AC
UVZ3-24V DC
STZ2-220V AC
Shunt Release 125 AF (220VAC, 380VAC, 24VDC) STZ2-380V AC
STZ2-24V DC
STZ3-220V AC
Shunt Release 250 AF (220VAC, 380VAC, 24VDC) STZ3-380V AC
STZ3-24V DC
Accessories for ACE MCCB
Product Description Reference MRP (`)(`)(`)(`)(`)
POR
POR
POR
POR
POR
MRP w.e.f. 19th April 2011 41
Switch Disconnector Fuse Unit without Fuse LinksLT Heavy Duty Switch Disconnector Fuse Unit CSSDF 32A - 800A, 415V, 50Hz complete with Handle Assembly having Door Interlock and Padlocking arrangement
D I N ((((( `̀̀̀̀ ))))) B S ((((( `̀̀̀̀ ))))) D I N ((((( `̀̀̀̀ ))))) B S ((((( `̀̀̀̀ ))))) D I N B S
2P CSSDF32D2 *----- CSSDF32B2 *-----
TP CSSDF32D3 1200 CSSDF32B3 1300 N o t A v a i l a b l e N o t A v a i l a b l e -32A
TPN CSSDF32D3N 1300 CSSDF32B3N 1350 E-CSSDF32D3N 2700 E-CSSDF32B3N 2700 CDFL00 (3 2 ) C T I A - 3 2 ( A 2 )
4P CSSDF32D4FN 1880 CSSDF32B4FN 1900 E-CSSDF32D4FN 3000 E-CSSDF32B4FN 3000
2P CSSDF63D2 *----- CSSDF63B2 *-----
TP CSSDF63D3 1800 CSSDF63B3 1700 N o t A v a i l a b l e N o t A v a i l a b l e - -63A
TPN CSSDF63D3N 2050 CSSDF63B3N 1800 E-CSSDF63D3N 3450 E-CSSDF63B3N 3200 CDFL00 (63) C T I S - 6 3 ( A 3 )
4P CSSDF63D4FN 2325 CSSDF63B4FN 2300 E-CSSDF63D4FN 3600 E-CSSDF63B4FN 3600
2P CSSDF100D2 *----- CSSDF100B2 *-----
TP CSSDF100D3 4200 CSSDF100B3 3600 N o t A v a i l a b l e N o t A v a i l a b l e -100A
TPN CSSDF100D3N 4400 CSSDF100B3N 3800 E-CSSDF100D3N 5900 E-CSSDF100B3N 5600 CDFL00 (100) C T C P - 1 0 0 ( A 4 )
4P CSSDF100D4FN 5325 CSSDF100B4FN 5100 E-CSSDF100D4FN 6600 E-CSSDF100B4FN 6500
2P CSSDF125D2 *----- CSSDF125B2 *-----
TP CSSDF125D3 4600 CSSDF125B3 4400 N o t A v a i l a b l e N o t A v a i l a b l e -125A
TPN CSSDF125D3N 5050 CSSDF125B3N 4650 E-CSSDF125D3N 6800 E-CSSDF125B3N 6400 CDFL00 ( 125) C T C P - 1 2 5 ( A 4 )
4P CSSDF125D4FN 6500 CSSDF125B4FN 5850 E-CSSDF125D4FN 7000 E-CSSDF125B4FN 7400
2P CSSDF160D2 *----- CSSDF160B2 *-----
TP CSSDF160D3 5100 CSSDF160B3 5300 N o t A v a i l a b l e N o t A v a i l a b l e -160A
TPN CSSDF160D3N 5700 CSSDF160B3N 5400 E-CSSDF160D3N 7400 E-CSSDF160B3N 7100 CDFL00 (160) C T F - 1 6 0 ( B 2 )
4P CSSDF160D4FN 7550 CSSDF160B4FN 6850 E-CSSDF160D4FN 9200 E-CSSDF160B4FN 9700
2P CSSDF200D2 *----- CSSDF200B2 *-----
TP CSSDF200D3 5800 CSSDF200B3 5600 N o t A v a i l a b l e N o t A v a i l a b l e -200A
TPN CSSDF200D3N 6300 CSSDF200B3N 5800 E-CSSDF200D3N 8500 E-CSSDF200B3N 7500 CDFL -1 -200 C T F - 2 0 0 ( B 2 )
4P CSSDF200D4FN 7600 CSSDF200B4FN 7000 E-CSSDF200D4FN 9800 E-CSSDF200B4FN 10200
2P CSSDF250D2 *----- CSSDF250B2 *-----
TP CSSDF250D3 7800 CSSDF250B3 7500 N o t A v a i l a b l e N o t A v a i l a b l e -250A
TPN CSSDF250D3N 8200 CSSDF250B3N 7600 E-CSSDF250D3N 10200 E-CSSDF250B3N 9600 CDFL -1 -250 CTF -250 ( B2 )
4P CSSDF250D4FN 9750 CSSDF250B4FN 9000 E-CSSDF250D4FN 11200 E-CSSDF250B4FN 11800
2P CSSDF315D2 *----- CSSDF315B2 *-----
TP CSSDF315D3 9100 CSSDF315B3 9100 N o t A v a i l a b l e N o t A v a i l a b l e -315A
TPN CSSDF315D3N 10200 CSSDF315B3N 9900 E-CSSDF315D3N 12600 E-CSSDF315B3N 13000 CDFL -2 -315 C T K F - 3 1 5 ( B 3 )
4P CSSDF315D4FN 12800 CSSDF315B4FN 12500 E-CSSDF315D4FN 15100 E-CSSDF315B4FN 15600
2P CSSDF400D2 *----- CSSDF400B2 *-----
TP CSSDF400D3 11400 CSSDF400B3 11400 N o t A v a i l a b l e N o t A v a i l a b l e -400A
TPN CSSDF400D3N 12500 CSSDF400B3N 11700 E-CSSDF400D3N 13300 E-CSSDF400B3N 14700 CDFL -2 -400 C T M F - 4 0 0 ( B 4 )
4P CSSDF400D4FN 14650 CSSDF400B4FN 14600 E-CSSDF400D4FN 16000 E-CSSDF400B4FN 17200
2P CSSDF630D2 *----- CSSDF630B2 *-----
TP CSSDF630D3 17700 CSSDF630B3 19100 N o t A v a i l a b l e N o t A v a i l a b l e -630A
TPN CSSDF630D3N 19500 CSSDF630B3N 19900 E-CSSDF630D3N 21300 E-CSSDF630B3N 24800 CDFL -3 -630 C T T M - 6 3 0 ( C 2 )
4P CSSDF630D4FN 21200 CSSDF630B4FN 21100 E-CSSDF630D4FN 25900 E-CSSDF630B4FN 28500
2P CSSDF800D2 *----- CSSDF800B2 *-----
TP CSSDF800D3 20600 CSSDF800B3 21400 N o t A v a i l a b l e N o t A v a i l a b l e -800A
TPN CSSDF800D3N 24100 CSSDF800B3N 25200 N o t A v a i l a b l e E-CSSDF800B3N 26500 - C T L M - 8 0 0 ( C 3 )
4P CSSDF800D4FN 26200 CSSDF800B4FN 26600 N o t A v a i l a b l e E-CSSDF800B4FN 31000
Notes: * 2 Pole switch prices available on request.
R a t i n gA m p s
Poles R e f e r e n c e M R P R e f e r e n c e M R P R e f e r e n c e M R P R e f e r e n c e M R P
CSSDF in Open Execution CSSDF in Sheet Steel EnclosureRecommended Fuse Links Type
(IEC Size)
SDFSDFSDFSDFSDF
MRP w.e.f. 19th April 201142
Auxiliary Contacts1 NO + 1 NC CSSDF 32A - 63A CSSDFZX 46 400
2 NO + 2 NC CSSDF 32A - 63A CSSDFZX 32 740
1 NO + 1 NC CSSDF 100A - 160A CSSDFZX 1 400
2 NO + 2 NC CSSDF 100A - 160A CSSDFZX 16 740
1 NO + 1 NC CSSDF 200A - 400A CSSDFZX 33 400
2 NO + 2 NC CSSDF 200A - 400A CSSDFZX 34 740
1 NO + 1 NC CSSDF 630A - 800A CSSDFZX 35 400
2 NO + 2 NC CSSDF 630A - 800A CSSDFZX 36 740
Handle Mounting Kit (for independent mounting of O/E Switches)
CSSDF 200A - 400A HMK-1-2 1010
CSSDF 630A - 800A HMK-3-2 1060
Spare Poles ( Price per Pole )
Rating Reference(Amps)
DIN BS
32 CSSDF-SP-32D CSSDF-SP-32B 720
63 CSSDF-SP-63D CSSDF-SP-63B 920
100 CSSDF-SP-100D CSSDF-SP-100B 1700
125 CSSDF-SP-125D CSSDF-SP-125B 1920
160 CSSDF-SP-160D CSSDF-SP-160B 2230
200 CSSDF-SP-200D CSSDF-SP-200B 2590
250 CSSDF-SP-250D CSSDF-SP-250B 3530
315 CSSDF-SP-315D CSSDF-SP-315B 3950
400 CSSDF-SP-400D CSSDF-SP-400B 5070
630 CSSDF-SP-630D CSSDF-SP-630B 7210
800 -- CSSDF-SP-800B 8800
Castle Key Locks
CSSDF 32A - 160A CSSDFZW-15 2620
CSSDF 200A - 800A CSSDFZW-4 2620
Key Interlocks (3 Locks - 2 Keys)
For Switch Type Reference MRP (`)(`)(`)(`)(`)
CSSDF 32A - 160A CSSDFZW-16 3120
CSSDF 200A - 800A CSSDFZW-5 2620
Spare Handle Shaft
C S SDF 3 2 A -160A CSP6X 1 6 5 190
C S SDF 2 0 0 A - 8 0 0 A CSP1 2 X 2 5 5 320
ACCESSORIES Switch Disconnector Fuse Unit
Extended Terminals
TPN E T - 3 2 3 1803 2 A- 6 3 A
4P E T - 3 2 4 250
T P N E T - 327 340100A- 160A
4P E T - 328 410
T P N E T - 3 2 9 710200A- 400A
4P E T - 3 30 890
For Switch Type Reference MRP (`)(`)(`)(`)(`)
SPARESSpare Neutral Links
C S S DF 3 2 A - 6 3 A C S S D F Z X 8 7 240
C S S D F 100A -160A C S S D F Z X 8 6 310
C S S D F 2 0 0 A - 4 0 0 A C S S D F Z X 8 5 530
C S S D F 6 3 0 A - 8 0 0 A C S S D F Z X 8 8 600
For Switch Type Reference MRP (`)(`)(`)(`)(`)
Spare Handle
CSSDF 32A-160A (Mou lded ) CSWH 80 S6 420
CSSDF 200A-400A (Mou lded) CSWH 145 S12 720
C S S DF 6 3 0 A - 8 0 0 A ( Moulded) C SWH 220 S12 910
SWITCH DISCONNECTOR FUSE UNIT WITH VARIOUS OPTIONS
Fuse Cover and Terminal Shroud are also on request
200A DIN/BS~630A DIN
Centre Mechanism, Fuse Cover and TerminalShroud are also on request 200A DIN/BS~630A DIN
MRP( ` )( ` )( ` )( ` )( ` )
SDF - ACCESSORIESSDF - ACCESSORIESSDF - ACCESSORIESSDF - ACCESSORIESSDF - ACCESSORIES
Compact SDFRating: 32A~63A
MRP w.e.f. 19th April 2011 43
2 CSSD125DM2 *
125 3 CSSD125DM3 4000 E-CSSD125DM3 5600
4 CSSD125DM4 4900 E-CSSD125DM4 6480
2 CSSD160DM2 *
160 3 CSSD160DM3 4400 E-CSSD160DM3 6300
4 CSSD160DM4 5300 E-CSSD160DM4 7200
2 CSSD200DM2 *
200 3 CSSD200DM3 5700 E-CSSD200DM3 7000
4 CSSD200DM4 7400 E-CSSD200DM4 8500
2 CSSD250DM2 *
250 3 CSSD250DM3 6700 E-CSSD250DM3 8400
4 CSSD250DM4 7800 E-CSSD250DM4 9500
2 CSSD315DM2 *
315 3 CSSD315DM3 8600 E-CSSD315DM3 10300
4 CSSD315DM4 10000 E-CSSD315DM4 12000
2 CSSD400DM2 *
400 3 CSSD400DM3 9900 E-CSSD400DM3 12000
4 CSSD400DM4 11500 E-CSSD400DM4 13570
2 CSSD400K2 *
400 3 CSSD400K3 POR E-CSSD400K3 POR
4 CSSD400K4 POR E-CSSD400K4 POR
2 CSSD630K2 *
630 3 CSSD630K3 16300 E-CSSD630K3 18900
4 CSSD630K4 17000 E-CSSD630K4 21000
2 CSSD800K2 *
800 3 CSSD800K3 19800 E-CSSD800K3 21900
4 CSSD800K4 20500 E-CSSD800K4 24500
2 CSSD1000K2 *
1000 3 CSSD1000K3 23500 E-CSSD1000K3 34700
4 CSSD1000K4 31000 E-CSSD1000K4 45500
2 CSSD1250K2 *
1250 3 CSSD1250K3 32500 E-CSSD1250K3 49200
4 CSSD1250K4 42500 E-CSSD1250K4 58500
2 CSSD1600K2 *
1600 3 CSSD1600K3 39300 E-CSSD1600K3 53700
4 CSSD1600K4 54000 E-CSSD1600K4 70500
3 CSSD1800K3 60000 E-CSSD1800K3 79300
1800 4 CSSD1800K4 74000 E-CSSD1800K4 91500
3 CSSD2500K3 92600 E-CSSD2500K3 118900
2500 4 CSSD2500K4 103000 E-CSSD2500K4 139000
3 CSSD3150K3 114000 E-CSSD3150K3 158300
3150 4 CSSD3150K4 130000 E-CSSD3150K4 181000
"*" Moulded Pole ConstructionLT Heavy Duty Load Break Switches CSSD 25A - 125A, 415V, 50Hz complete with Rotary Handle Assembly having door interlock and padlocking arrangement.
Switch Disconnectors (Load Break Switches)
Reference MRP (`)(`)(`)(`)(`) Reference MRP (`)(`)(`)(`)(`)
3 CSSD25D3 1075 E-CSSD25D3 220025
4 CSSD25D4 1375 E-CSSD25D4 23703 CSSD40D3 1330 E-CSSD40D3 2550
404 CSSD40D4 2100 E-CSSD40D4 27503 CSSD63K3 1600 E-CSSD63K3 3000
634 CSSD63D4 2275 E-CSSD63D4 36003 CSSD125D3 3600 E-CSSD125D3 5000
1254 CSSD125D4 4400 E-CSSD125D4 5600
Modular Pole constructionLT Heavy Duty Load Break Switches CSSD 125A - 3150A, 415V, 50Hz complete with Handle Assembly having door interlock and padlocking arrangement.
"*" The above switches are available with door defeate Mechanism / Pistol grip handle.
Notes: * 2 Pole switch prices available on request.
Handle colour: Red Knob and Yellow Base (standard) Black Base and Knob on request.
Reference MRP (`)(`)(`)(`)(`) Reference MRP (`)(`)(`)(`)(`)
CSSD In Open Execution In Sheet Steel EnclosureRating(Amps) Poles
CSSD in Open Execution CSSD in Sheet Steel EnclosureRating(Amps)
Poles
SDSDSDSDSD K
Se
ries
Refe
r C
om
pa
ct s
erie
s fo
r 12
5-40
0A (
DM
Se
ries)
MRP w.e.f. 19th April 201144
Moulded SwitchesPlastic Enclosure
Rating Colour(Amps) Box Handle
25 3Grey Black EABW CSSD 25 D3 1130
Yellow Red EACL CSSD 25 D3 1220
25 4Grey Black EABW CSSD 25 D4 1220
Yellow Red EACL CSSD 25 D4 1280
40 3Grey Black EABW CSSD 40 D3 1330
Yellow Red EACL CSSD 40 D3 1390
40 4Grey Black EABW CSSD 40 D4 1390
Yellow Red EACL CSSD 40 D4 1450
63 3Grey Black EABW CSSD 63 K3 1490
Yellow Red EACL CSSD 63 K3 1560
Toggle SwitchesWith Toggle type operating knob
CSSD in Open Execution
RatingAmps
Poles Reference MRP (`)(`)(`)(`)(`)
3 CSSD25C3 81025
4 CSSD25C4 920
3 CSSD40C3 98040
4 CSSD40C4 1130
3 CSSD63C3 110063
4 CSSD63C4 1220
Moulded SwitchesIn Aluminium Alloy Enclosure
RatingPoles ReferenceAmps MRP (`)(`)(`)(`)(`)
163 CSSD16D3 20804 CSSD16D4 2430
253 CSSD25D3 25504 CSSD25D4 2720
303 CSSD30D3 26704 CSSD30D4 2840
403 CSSD40D3 28904 CSSD40D4 3100
63 3 CSSD63K3 353080 3 CSSD80D3 3820
100 3 CSSD100D3 4630
125 3 CSSD125D3 5500
3D View of Switches
Please replace with ELCL or ELBLELCL Rotary handle colour: Red Rotary Knob, Yellow Knob base.ELBL Rotary handle colour: Black Knob & base.
Poles Reference MRP (`)(`)(`)(`)(`)
SWITSWITSWITSWITSWITCHESCHESCHESCHESCHES
N o n S t o c k a b l e i t e m
MRP w.e.f. 19th April 2011 45
For Switch Type Pole ReferenceMRP( ` )( ` )( ` )( ` )( ` )
1 NO + 1 NC CSSD 25A-40A 3 CSSDZX 49 410
2 NO + 2 NC CSSD 25A-40A 3 CSSDZX 50 760
1 NO + 1 NC CSSD 25A-40A 4 CSSDZX 87 410
2 NO + 2 NC CSSD 25A-40A 4 CSSDZX 88 760
1 NO + 1 NC CSSD 63A 3 CSSDZX 79 410
2 NO + 2 NC CSSD 63A 3 CSSDZX 80 760
1 NO + 1 NC CSSD 125A 3 CSSDZX 52 410
2 NO + 2 NC CSSD 125A 3 CSSDZX 53 760
1 NO + 1 NC CSSD 63A-125A 4 CSSDZX 55 410
2 NO + 2 NC CSSD 63A-125A 4 CSSDZX 56 760
Switch Disconnectors (Moulded construction)ACCESSORIES: Auxiliary Contacts
Castle Key Locks
CSSD 25A-160A CSSDZW - 15CSSD 200A-3150A CSSDZW - 4
2620
Spare Handle ShaftCSSD 25A-125A CSP5X70 130
Switch Poles ( Price per Pole )125A (Compact) CSSD-SP-125DM 980160A (Compact) CSSD-SP-160DM 1130200A (Compact) CSSD-SP-200DM 1300250A (Compact) CSSD-SP-250DM 1740315A (Compact) CSSD-SP-315DM 2540200A CSSD-SP200D 3180250A CSSD-SP250K 3290400A CSSD-SP400K 4880630A CSSD-SP630K 5600800A CSSD-SP800K 73901000A CSSD-SP1000K 112101250A CSSD-SP1250K 140401600A CSSD-SP1600K 162301800A CSSD-SP1800K 25070
Rotary Knob Handles
For Switch Type ReferenceMRP((((( `̀̀̀̀ )))))
CSSD 25A-125A (Moulded-Red/Yellow) CSSDZX108 240
CSSD 25A-125A (Moulded-Black) CSSDZX111BL 240
RatingPole Reference
MRP(Amps) ( ` )( ` )( ` )( ` )( ` )
125TPN ET-325 360
4 ET-326 390
SPARES: Extended Terminals
For Switch Type Pole ReferenceMRP( ` )( ` )( ` )( ` )( ` )
1 NO + 1 NC CSSD 125A-160A (Compact) 3/4 CSSDZX 1 410
2 NO + 2 NC CSSD 125A-160A (Compact) 3/4 CSSDZX 16 760
1 NO + 1 NC CSSD 200A-315A (Compact) 3/4 CSSDZX 37 410
2 NO + 2 NC CSSD 200A-315A (Compact) 3/4 CSSDZX 38 760
1 NO + 1 NC CSSD 200A-800A 3/4 CSSDZX 33 410
2 NO + 2 NC CSSD 200A-800A 3/4 CSSDZX 34 760
1 NO + 1 NC CSSD 1000A-3150A 3/4 CSSDZX 35 410
2 NO + 2 NC CSSD 1000A-3150A 3/4 CSSDZX 36 760
Key Interlocks (3 Locks - 2 Keys)
For Switch Type ReferenceMRP( ` )( ` )( ` )( ` )( ` )
CSSD 125A-160A CSSDZW - 16
CSSD 200A-3150A CSSDZW - 53120
Switch Handles
For Switch Type ReferenceMRP((((( `̀̀̀̀ )))))
CSSD 200A-800A (Moulded) CSWH 145 S12 720
CSSD 1000A-1800A (Moulded) CSWH 220 S12 910
CSSD 2500A-3150A (Moulded) CSWH 220 S12 910CSSD 2500A-3150A (Metallic) CSDA8 1080CSSD 125A-160A (Compact) (Moulded) CSWH 80 S6 390
CSSD 200A-315A (Compact) (Moulded) CSWH80 S8 390Door Mounting Kit (for mounting Switch on door instead of base plate)
For Switch Type Pole ReferenceMRP( ` )( ` )( ` )( ` )( ` )
CSSD 25A-63A 3 DMK-1
CSSD 25A-40A 4 DMK-1A
CSSD 125A 3 DMK-2
CSSD 63A-125A 4 DMK-3
Switch Handle Shaft
CSSD 125A-160A (Compact) CSP6X165 190CSSD 200A-315A (Compact) CSP8X240 190CSSD 200A-1800A CSP12X255 320CSSD 2500A-3150A CSP12X325 390
Note: Key & Castle Locks are available on request.
Switch Disconnectors (Modular construction)ACCESSORIES: Auxiliary Contacts
Handle Mounting Kit (for independent mounting of O/E Switches)
CSSD 200A-315A (Compact Series) HMK-2
CSSD 200A-800A HMK-1-11010
CSSD 1000A-1800A HMK-3-1 1090
Extended Terminals for Switch Disconnectors
RatingPole Reference
MRP(Amps) ( ` )( ` )( ` )( ` )( ` )
125~160 (Compact)TPN ET-327 3504P ET-328 420
200~400TPN ET-329 7504P ET-330 920
SPARES
SD - ACCESSORIESSD - ACCESSORIESSD - ACCESSORIESSD - ACCESSORIESSD - ACCESSORIES
270
MRP w.e.f. 19th April 201146
In open execution, 4 pole
On Load Change-over Switches (Back To Back Type)LT Heavy Duty 4 Pole On Load Changeover Load Break Switch compris ing of two Switches 63A - 1800A, 415V, 50Hz complete with handle assemblyhaving Door Inter lock and Padlock ing ar rangement.
In Sheet Steel Enclosure
4 Pole in Open Execution 4 Pole in Sheet Steel Enclosure
Switch Disconnector Fuse ChangeoverLT Switch Disconnector Fuse Changeover complete with Handle Assembly having Door Interlock and Padlocking arrangement without fuses.
RatingPoles # Reference MRP ((((( `̀̀̀̀))))) Reference MRP ((((( `̀̀̀̀)))))(Amps)
63 4 CSCS63DM4CO 4050 E-CSCS63DM4CO 5800
80 4 CSCS80DM4CO 5350 E-CSCS80DM4CO 7400
100 4 CSCS100DM4CO 6400 E-CSCS100DM4CO 8200
125 4 CSCS125DM4CO 7700 E-CSCS125DM4CO 10400
160 4 CSCS160DM4CO 8450 E-CSCS160DM4CO 11500
200 4 CSCS200DM4CO 10400 E-CSCS200DM4CO 13200
250 4 CSCS250DM4CO 14800 E-CSCS250DM4CO 18200
315 4 CSCS315DM4CO 15500 E-CSCS315DM4CO 19000
400 4 CSCS400DM4CO 21500 E-CSCS400DM4CO 28000
400 4 CSCS400K4CO POR E-CSCS400K4CO POR
630 4 CSCS630K4CO 26500 E-CSCS630K4CO 32300
800 4 CSCS800K4CO 38800 E-CSCS800K4CO 47000
1000 4 CSCS1000K4CO 64400 E-CSCS1000K4CO 81000
1250 4 CSCS1250K4CO 92000 E-CSCS1250K4CO 109000
1600 4 CSCS1600K4CO 127000 E-CSCS1600K4CO 147000
1800 4 CSCS1800K4CO 140000 E-CSCS1800K4CO 181000
2000 4 CSCS2000K4CO 156000 E-CSCS2000K4CO 191000
2500 4 CSCS2500K4CO 208000 E-CSCS2500K4CO 248000
3150 4 CSCS3150K4CO 285000 E-CSCS3150K4CO 335000
RatingReference
MRPReference
MRP Recommended Fuse Links Type(Amps) ((((( `̀̀̀̀ ))))) ((((( `̀̀̀̀ ))))) (IEC Size) BS
125 CSCF125B4CO 10940 E-CSCF125B4CO 14020 CTF-125(B2)
160 CSCF160B4CO 11690 E-CSCF160B4CO 15410 CTF-160(B2)
200 CSCF200B4CO 19980 E-CSCF200B4CO 23990 CTF-200(B2)
250 CSCF250DB4CO 20150 E-CSCF250B4CO 24660 CTKF-250(B3)
315 CSCF315B4CO 20820 E-CSCF315B4CO 25720 CTKF-315(B3)
400 CSCF400B4CO 29880 E-CSCF400B4CO 37290 CTMF-400(B4)
630 CSCF630B4CO 34900 E-CSCF630B4CO 42570 CTTM-630(C2)
800 CSCF800B4CO 43300 E-CSCF800B4CO 48870 CTLM-800(C3)
CHANGEOVERCHANGEOVERCHANGEOVERCHANGEOVERCHANGEOVER
Compact Changeover Switch from 40A ~ 200A
In open execution, 4 pole In Sheet Steel Enclosure
RatingPoles # Reference MRP ((((( `̀̀̀̀))))) Reference MRP ((((( `̀̀̀̀)))))(Amps)
40 4 CSCS40P4COB 3150 E-CSCS40P4COB 4800
63 4 CSCS63P4COB 3600 E-CSCS63P4COB 5000
100 4 CSCS100P4COB 5000 E-CSCS100P4COB 6400
125 4 CSCS125P4COB 6700 E-CSCS125P4COB 9000
160 4 CSCS160P4COB 7400 E-CSCS160P4COB 9700
200 4 CSCS200P4COB 8900 E-CSCS200P4COB 11300
N o n S t o c k a b l e i t e m
MRP w.e.f. 19th April 2011 47
RatingPoles Reference MRP ((((( `̀̀̀̀))))) (Amps)
63 4 CSBS63DM4 10700
80 4 CSBS80DM4 11600100 4 CSBS100DM4 12100125 4 CSBS125DM4 13100160 4 CSBS160DM4 15500200 4 CSBS200DM4 16700250 4 CSBS250DM4 24200315 4 CSBS315DM4 25200400 4 CSBS400K4 37800630 4 CSBS630K4 42900800 4 CSBS800K4 55100
1000 4 CSBS1000K4 99500
1250 4 CSBS1250K4 136700
1600 4 CSBS1600K4 183500
1800 4 CSBS1800K4 213000
In Open Execution
RatingPoles Reference MRP ((((( `̀̀̀̀)))))(Amps)
63 4 E-CSBS63DM4 13400
80 4 E-CSBS80DM4 14300100 4 E-CSBS100DM4 14700125 4 E-CSBS125DM4 16800160 4 E-CSBS160DM4 18100200 4 E-CSBS200DM4 20500250 4 E-CSBS250DM4 29400315 4 E-CSBS315DM4 31000400 4 E-CSBS400K4 44100630 4 E-CSBS630K4 50400800 4 E-CSBS800K4 74600
1000 4 E-CSBS1000K4 122900
1250 4 E-CSBS1250K4 165900
1600 4 E-CSBS1600K4 219500
1800 4 E-CSBS1800K4 243100
In Sheet Steel Enclosure
Bypass SwitchesLT By Pass Switch complete with Handle Assembly having Door Interlock and Padlocking arrangement.
Spare Poles ( Price per Pole )
RatingType Reference MRP ((((( `̀̀̀̀)))))(Amps)
63 CSCS/CSBS CSSD-SP-63DM 86080 CSCS/CSBS CSSD-SP-80DM 870
100 CSCS/CSBS CSSD-SP-100DM 960125 CSCS/CSBS/CSCF CSSD-SP-125DM 980160 CSCS/CSBS/CSCF CSSD-SP-160DM 1130200 CSCS/CSBS/CSCF CSSD-SP200DM 1300250 CSCS/CSBS/CSCF CSSD-SP250DM 1740315 CSCS/CSBS/CSCF CSSD-SP315DM 2540400 CSCS/CSBS/CSCF CSCS-SP400K 4880630 CSCS/CSBS/CSCF CSCS-SP630K 5600800 CSCS/CSBS/CSCF CSCS-SP800K 7390
1000 CSCS/CSBS CSCS-SP1000K 112101250 CSCS/CSBS CSCS-SP1250K 140401600 CSCS/CSBS CSCS-SP1600K 161701800 CSCS/CSBS CSCS-SP1800K 25070
Spare Handle
Type Reference MRP (`)(`)(`)(`)(`)
CSCS/CSBS 63-315A/CSCF125-315A CCOH 145 S12 600
CSCS/CSBS 400A-1800A/CSCF400-800A CCOH 220 S12 780
CSCS 2000A-3150A (Moulded) CCOT 320 S12 880
CSCS 2000A-3150A (Metallic) CSDA6 880
Spare Handle Shaft
CSCS 63-315A
CSBS 63-315A
CSCF125-315A
CSCS 400A-1800A CSP12X205 230
CSCS 2000A-3150A
CSBS 400A-1800A
CSCF 400A-1800A
Type Reference MRP (`)(`)(`)(`)(`)
Table of Operation
Handle Switch - I Switch - II Switch - IIl Remarks
Position - I ON OFF ON RegulatedSupply to Load
No Supply, Load aswell as RegulatorIsolated from IncomingSource
Position - II OFF ON OFFDirect Supply,Regulator By-passed& Isolated
Bypass Switch application
Position - O OFF OFF OFF
Auxiliary Contacts
ContactsFor Switch Type
Qty./Reference
MRPConfiguration Switch ( ` )( ` )( ` )( ` )( ` )
1 NO + 1 NCCSCS/CSBS 63A-160A Upper
CSCF 125A-160A1 CSCSZX1-U 380
1 NO + 1 NCCSCS/CSBS 63A-160A LowerCSCF 125A-160A
1 CSCSZX1-L 380
2 NO + 2 NCCSCS/CSBS 63A-160A UpperCSCF 125A-160A
1 CSCSZX3-U 750
2 NO + 2 NCCSCS/CSBS 63A-160A LowerCSCF 125A-160A
1 CSCSZX3-L 750
1 NO + 1 NCCSCS/CSBS 200A-1800ACSCF 200A-800A
2 CSCSZX2 760
2 NO + 2 NCCSCS/CSBS 200A-1800ACSCF 200A-800A
2 CSCSZX4 1490
ACCESSORIES (CSCS/CSBS/CSCF)
Notes : If changeovers switch is required with Auxiliary contacts, please orderthe same separately. Prices listed are for the pair of auxiliary contacts,if applicable.
Notes : for one changeover of 4 pole, 8 Nos of sparepoles are requied.
BBBBBYPYPYPYPYPASS SWITASS SWITASS SWITASS SWITASS SWITCHESCHESCHESCHESCHES
CSP12/8X200 210
CSP12X305 380
N o n S t o c k a b l e i t e m
MRP w.e.f. 19th April 201148
Switch Disconnector Fuse Changeover - Conventional Type (Side-by-Side)LT Heavy Duty 4 Pole Changeover Switch Disconnector Fuse unit comprising of two Switches, 32A - 800A, 415V, 50Hz mounted on common chasis completewith Mechanical Interlock and Handle Assembly having Door Interlock & Padlocking arrangements (without Fuses)
CSSDF in Open Execution, 4 Pole
Reference
DIN BS
32 CSSDF32D4CO CSSDF32B4CO 6100
63 CSSDF63D4CO CSSDF63B4CO 7400
100 CSSDF100D4CO CSSDF100B4CO 11500
125 CSSDF125D4CO CSSDF125B4CO 13300
160 CSSDF160D4CO CSSDF160B4CO 17200
200 CSSDF200D4CO CSSDF200B4CO 22550
250 CSSDF250D4CO CSSDF250B4CO 24800
315 CSSDF315D4CO CSSDF315B4CO 26200
400 CSSDF400D4CO CSSDF400B4CO 35000
630 CSSDF630D4CO CSSDF630B4CO 49300
800 NA CSSDF800B4CO 57300
Load Break Changeover-Conventional Type (Side-by-Side)LT Heavy Duty 4 Pole Changeover Load Break Switch comprising of two Switches 25A - 3150A, 415V, 50Hz mounted on common chasis complete withMechanical Interlock and Handle Assembly having Door Interlock and Padlocking arrangements.
CSSD in Open Execution, 4 Pole
Rating(Amps)
25 CSSD25D4CO 4540
40 CSSD40D4CO 5280
63 CSSD63D4CO 5550
125 CSSD125DM4CO 10260
200 CSSD200DM4CO 13100
250 CSSD250DM4CO 18070
400 CSSD400K4CO 28300
630 CSSD630K4CO 33410
800 CSSD800K4CO 45490
1000 CSSD1000K4CO 82450
1250 CSSD1250K4CO 98560
1600 CSSD1600K4CO 133270
1800 CSSD1800K4CO 168260
2500 CSSD2500K4CO 304140
3150 CSSD3150K4CO 362720
Shorting Links / Busbars NOT provides with open executionChangeover Switches
Enclosure Prices on request.
Spare Handles
ACCESSORIES Changeover Switches (CSSDF)
For Switch Type Reference MRP (`)(`)(`)(`)(`)
CSSDF 32A - 160A (Moulded) CCOH 90 S6 410
CSSDF 200A - 400A (Moulded) CCOH 220 S12 760
CSSDF 630A - 800A (Moulded) CCOT 320 S12 830
CSSDF 630A - 800A (Metallic) CSDA6 880
For CSSDF Changeover Switches
Operating Mechanism
For Switch Type Reference MRP (`)(`)(`)(`)(`)
CSSDF 32A-160A CSSDFZW1 2420
CSSDF 200A-400A CSSDZW12/1 6780
CSSDF 630A-800A CSSDZW12 8350
Accessories Changeover Switch (CSSD)Spare Handles
For Switch Type Reference MRP (`)(`)(`)(`)(`)
CSSD 25A-125A (Moulded) CCOH 90 S6 420
CSSD 200A-800A (Moulded) CCOH 220 S12 770
CSSD 1000A-3150A (Moulded) CCOT 320 S12 850
CSSD 1000A-3150A (Metallic) CSDA6750 900
For CSSD Changeover Switches
Operating Mechanism
For Switch Type Reference MRP (`)(`)(`)(`)(`)
CSSD 25A - 40A CSSDZW6 2260
CSSD 63A - 125A CSSDZW6/1 2390
CSSD 200A - 800A CSSDZW11 4970
CSSD 1000A - 3150A CSSDZW12 8350
Rating(Amps)
MRP (`)(`)(`)(`)(`)
Reference MRP (`)(`)(`)(`)(`)
SDF CHANGEOVERSDF CHANGEOVERSDF CHANGEOVERSDF CHANGEOVERSDF CHANGEOVER
N o n S t o c k a b l e i t e m
OFF Load side handle Changeover Switch 4 Pole
Rating (Amps)
32 CSCSOF32CO4 2300
63 CSCSOF63CO4 4700
100 CSCSOF100CO4 9200
200 CSCSOF200CO4 14000
315 CSCSOF315CO4 18000
400 CSCSOF400CO4 POR
ReferenceMRP (`)(`)(`)(`)(`)
MRP w.e.f. 19th April 2011 49
HRC FusesLow watt losses & low let thru energy HRC Fuse Links tested for 80kA at 415V / 500V,as per IS :13703 (Pt.2 / Sec.1) and IEC 269 (Pt.1& 2), complete with indicators
DIN Type Fuse Links with Blade Contacts
.
O F A A 0 0 H 6 6
O F A A 0 0 H 1 0 1 0
O F A A 0 0 H 1 6 1 6
O F A A 0 0 H 2 0 2 0
O F A A 0 0 H 2 5 2 5
O F A A 0 0 H 3 2 3 2
O F A A 0 0 H 3 5 3 5
CDFL 00 6 6
CDFL 00 1 0 1 0
CDFL 00 1 6 1 6
CDFL 00 2 0 2 0
CDFL 00 2 5 2 5
CDFL 00 3 2 3 2
CDFL 00 3 5 3 5
CDFL 00 40 40
CDFL 00 5 0 5 0
CDFL 00 6 3 6 3
CDFL 00 8 0 8 0
CDFL 00 1 0 0 1 0 0
CDFL 00 1 2 5 1 2 5
CDFL 00 1 6 0 1 6 0
CDFL 1 3 2 3 2
CDFL 1 3 5 3 5
CDFL 1 5 0 5 0
CDFL 1 6 3 6 3
CDFL 1 8 0 8 0
CDFL 1 100 100
CDFL 1 125 125
CDFL 1 160 160
CDFL 1 200 200
CDFL 1 250 250 1 3 430
CDFL 2 100 100
CDFL 2 125 125
CDFL 2 160 160
CDFL 2 200 200
CDFL 2 250 250
CDFL 2 315 315
CDFL 2 400 400 2 3 620
CDFL 3 315 315
CDFL 3 400 400
CDFL 3 500 500
CDFL 3 630 630
Fuse Holders ( Fuse Fittings ) for Cylinderical HBC Fuse Links
CHO32R 32 14 x 51 10 110
CHC63R 63 14 x 51 10 140
HRC Fuse Bases & Fuse HoldersHRC Fuse Bases & Fuse Holders are tested for 80 kA at 415V / 500V, as perIS :13703 (Pt. 2 / Sec.1) and IEC 269 (Pt.1& 2)
FUSE Puller
CDFH 003 1 220
Fuse Holders ( Fuse Fittings ) for British Pattern Fuses Links
CNS20H 20 F1 10 100
CSM32H 32 A2 5 160
CSM63H 63 A3 5 200
CSM100H 100 A4 3 490
CSM100B* 100 A4 3 570
Solid Links
CDSL 00 00 3 260
CDSL 1 1 3 360
CDSL 2 2 3 550
CDSL 3 3 3 640
Fuse Bases for DIN Type Fuse Links
NOTE : 3- Phase version available on request.
CDFB 00-1-160 160 00 3 240
CDFB1 250 250 1 3 470
CDFB2 400 400 2 3 630
CDFB3 630 630 3 3 860
ReferenceInA
IECSize
Std. Pkg.(No's)
MRP (`)(`)(`)(`)(`)
ReferenceIECSize
Std. Pkg.(No's)
MRP (`)(`)(`)(`)(`)
ReferenceIECSize
Std. Pkg.(No's)
MRP (`)(`)(`)(`)(`)Rating(Amps)
ReferenceIECSize
Std. Pkg.(No's)
MRP (`)(`)(`)(`)(`)Rating(Amps)
Reference Std. Pkg. (No's) MRP (`)(`)(`)(`)(`)
ReferenceInA
IECSize
Std. Pkg.(No's)
MRP (`)(`)(`)(`)(`)
HRC FUSEHRC FUSEHRC FUSEHRC FUSEHRC FUSE
0 0 3 210
0 0 3 140
0 0 3 210
0 0 3 220
1 3 380
1 3 390
2 3 560
3 3 750
3 3 910
0 0 3 240
2 3 570
NOTE : All orders will be accepted only in standard packaging qty.
MRP w.e.f. 19th April 201150
British Pattern HRC Fuse Links
Central TAG (4 hole fixing ) Type
CTTM 450 450 C2 1 910
CTTM 500 500 C2 1 910
CTTM 630 630 C2 1 1370
Cylindrical HRC/FUSE LinksCHF 2, 4, 6, 8 & 10 (14*51) 20 90
CHF 16, 20 & 25 (14*51) 20 90
CHF 32 & 40 (14*51) 20 100
CHF 50 (14*51) 20 160
CHF 63 (14*51) 20 170
CGF 2, 4, 6, 8,10 & 16 (10*38) 20 30
CGF 20 & 25 (10*38) 20 30
CGF 32 (10*38) 20 40
CNS (Off Set) clip in Type
CNS 2, 4, 6, 8,10,12 & 16 F1 20 40
CNS 20, 25 & 32 F1 20 45
Central TAG (2 hole fixing) Type
CTC 80 80 B1 6
CTC 100 100 B1 6
CTC 125 125 B1 6
CTF 125 125 B2 3
CTF 160 160 B2 3
CTF 200 200 B2 3
CTF 250 250 B2 3
Off Set TAG Type
CTIA 4, 6,10,16, 20, 25 & 32 A2 10 70
CTIS 32, 35, 40, 50 & 63 A3 10 80
CTCP 50 50 A4 6
CTCP 63 63 A4 6
CTCP 80 80 A4 6
CTCP 100 100 A4 6
CTCP 125 125 A4 6
CTFP 125 125 - 3
CTFP 160 160 - 3
CTFP 200 200 - 3
CTKF 250 250 B3 1
CTKF 300 300 B3 1
CTKF 315 315 B3 1
CTMF 355 355 B4 1
CTMF 400 400 B4 1700
Low watt losses & low let thru energy HRC Fuse Links tested for 80kA at 415V / 500V, as per IS :13703 (Pt.2 / Sec.1) and IEC 269 (Pt.1& 2)
CTLM 670 670 C3 1
CTLM 710 710 C3 11530
CTLM 750 750 C3 1
CTLM 800 800 C3 11530
CTM 355 355 C1 1
CTM 400 400 C1 1700
CNIT 2, 4, 6, 8, 10, 12 & 16 A1 20 40
CNIT 20, 25, & 32 A1 20 45
ReferenceRating(Amps)
IEC SizeStd. Pkg.
(No's)MRP (`)(`)(`)(`)(`) Reference
Rating(Amps)
IEC SizeStd. Pkg.
(No's)MRP (`)(`)(`)(`)(`)
HRC FUSEHRC FUSEHRC FUSEHRC FUSEHRC FUSE
160
230
160
240
340
Power
ControlComponents
MPCBs
Mini Contactors
Contactors
Overload Relays
Motor Starters (Agro and Industrial)
Industrial Plugs & Sockets
MRP w.e.f. 19th April 2011 53
Motor Protection Circuit BreakerConforming IS13947-2 : IEC60947-2
0.02 0.1~0.16 100 TCMS-32S~0.16 1900 100 TCMS-32H~0.16 2650
0.06 0.16~0.25 100 TCMS-32S~0.25 1900 100 TCMS-32H~0.25 2650
0.09 0.25~0.4 100 TCMS-32S~0.4 1900 100 TCMS-32H~0.4 2650
0.12 0.4~0.63 100 TCMS-32S~0.63 2000 100 TCMS-32H~0.63 2700
0.25 0.5 0.63~1 100 TCMS-32S~1 2000 100 TCMS-32H~1 2800
0.55 0.75 1~1.6 100 TCMS-32S~1.6 2100 100 TCMS-32H~1.6 3000
0.75 1.5 1.6~2.5 100 TCMS-32S~2.5 2100 100 TCMS-32H~2.5 3000
1.5 2 2.5~4 100 TCMS-32S~4 2150 100 TCMS-32H~4 3000
2.2 5 4~6 100 TCMS-32S~6 2150 100 TCMS-32H~6 3000
3 5 5~8 100 TCMS-32S~8 2250 100 TCMS-32H~8 3000
4 7.5 6~10 50 TCMS-32S~10 2400 100 TCMS-32H~10 3200 1
5.5 7.5 9~13 50 TCMS-32S~13 2800 100 TCMS-32H~13 3300
7.5 10 11~17 20 TCMS-32S~17 2900 50 TCMS-32H~17 3300
7.5 15 14~22 15 TCMS-32S~22 2900 50 TCMS-32H~22 3300
11 15 18~26 15 TCMS-32S~26 3250 50 TCMS-32H~26 3700
15 20 22~32 15 TCMS-32S~32 5900 50 TCMS-32H~32 5800
18.5 30 28~40 50 TCMS-63H~40 8100
63AF 22 40 34~50 50 TCMS-63H~50 8800
30 50 45~63 50 TCMS-63H~63 9500
37 60 55~75 75 TCMS-100H~75 10000
100AF 45 75 70~90 75 TCMS-100H~90 10000
45 75 80~100 75 TCMS-100H~100 10200
TCMS-Model- Thermal Magnetic Adjustable thermal release Magnetic release 13 X Ie Max. Trip class 10 Ambient temperature compensation Phase failure protection
100 0.02 0.16 TCMS-32HI~0.16 2600
100 0.06 0.25 TCMS-32HI~0.25 2600
100 0.09 0.4 TCMS-32HI~0.4 2600
100 0.12 0.63 TCMS-32HI~0.63 2600
100 0.25 0.5 1 TCMS-32HI~1 2600
100 0.55 0.75 1.6 TCMS-32HI~1.6 2600
100 0.75 1.5 2.5 TCMS-32HI~2.5 2600
100 1.5 2 4 TCMS-32HI~4 2600
100 2.2 5 6 TCMS-32HI~6 2600
100 3 5 8 TCMS-32HI~8 2600 1
100 4 7.5 10 TCMS-32HI~10 2600
100 5.5 7.5 13 TCMS-32HI~13 2600
50 7.5 10 17 TCMS-32HI~17 2950
50 7.5 15 22 TCMS-32HI~22 2950
50 11 15 26 TCMS-32HI~26 2950
50 15 20 32 TCMS-32HI~32 5200
50 18.5 30 40 TCMS-63HI~40 7600
50 22 40 50 TCMS-63HI~50 7600
50 30 50 63 TCMS-63HI~63 8500
75 37 60 75 TCMS-100HI~75 9200
75 45 75 90 TCMS-100HI~90 9400
75 45 75 100 TCMS-100HI~100 9400
TCMS-Model-Magnetic (Short circuit protection only) Without thermal release Magnetic release 13 X Ie Max.
GLOBAL CERTIFICATION
High Breaking Capacity / Rotary HandleStandard Model/ Toggle Switch
Type / Frame
Frame Reference MRP (((((`̀̀̀̀)))))Rated Operational
Current Ie(A)
Power Rating 3-PhMotors AC3-duty
415V, 50Hz Kw HP
BreakingCapacity a415V,50Hz
Power Rating 3-PhMotors AC3-duty
415V, 50Hz Kw HP
Adjustmentrange(Amp)
Reference MRP ((((( `̀̀̀̀)))))Breakingcapacity
415V, 50Hz
Breakingcapacity
415V, 50HzReference MRP (((((`̀̀̀̀)))))
MPCB
32AF
32AF
63AF
100AF
N o n S t o c k a b l e i t e m
Std. Pkg.(No's)
Std. Pkg.(No's)
MRP w.e.f. 19th April 201154
Description Configuration Model MRP (((((`̀̀̀̀))))) Std. Pkg. (No's)
1NO+1NC TFX11 460
Auxiliary switch for front mounting 2NC TFX02 460
2NO TFX20 460
Auxiliary switch for front1NO+1NC TLX11 500 1
side mounting on the left2NC TLX02 500
2NO TLX20 500
Any trip alarm switch for1NO+1NC TLA11 600
side mounting on the left2NC TLA02 600
2NO TLA20 600
Magnetic trip alarm switchTLAM 625 1
for side mounting on the left
Shunt release for side110~127V50Hz TRS110~127V50Hz 1075
mounting on the right220~230V50Hz TRS220~230V50Hz 1075
415~440V50Hz TRS415~440V50Hz 1075
110~127V50Hz TRU110~127V50Hz 1075
220~230V50Hz TRU220~230V50Hz 1075
415~440V50Hz TRU415~440V50Hz 1075
110~127V50Hz TRUX110~127V50Hz 1150 1
220~230V50Hz TRUX220~230V50Hz 1150
415~440V50Hz TRUX415~440V50Hz 1150
Insulation Barrier (for TCMS-100H/100HI only) TIB100 300
TCMS-32S+TC1M06-16 TDA-16SA 300
TCMS-32S+TP1M06-16 TDA-16SD 300
TCMS-32H/32HI+TC1M06-16 TDA-16HA 300
TCMS-32H/32HI+TP1M06-16 TDA-16HD 300
2 PointPB322
PB632600 1
3 Point*PB323
PB633700 1
MPCB Enclosure (IP 65 Category) for TCMS-32H/HI EPH32-65S 900 1
Extension Shaft 115mm
TCMS-32H/HI MEH32-115
TCMS-63H/HI MEH63-115 7751
TCMS-100H/HI MEH100-115
Extension Shaft 315mm
TCMS-32H/HI MEH32-315
TCMS-63H/HI MEH63-315 10501
TCMS-100H/HI MEH100-315
Accessories for MPCBs
ACCESSORIES - MPCB
Extended Handle (Door Mounting with
Door Interlock, Defeat Interlock & Padlock)
Busbar
Adaptor kit for MPCB + Mini Contactors
Undervoltage release with switchfor side mounting on the right
Undervoltage release for sidemounting on the right
MRP w.e.f. 19th April 2011 55
Control Relays
Mini ContactorsConforming IS13947-4 : IEC60947-4
10 Amps
P lease speci fy Coi l Vo l tage.
Power Contactors3 Pole
P lease speci fy Coi l Vo l tage.
2 N O + 2 N C T C A 2 - M 2 2 T C A 3 - M 2 2
3 N O + 1 N C T C A 2 - M 3 1 T C A 3 - M 3 1
4 N O T C A 2 - M 4 0 7 2 5 1 0 T C A 3 - M 4 0 9 5 5 1 0
1 N O + 3 N C T C A 2 - M 1 3 T C A 3 - M 1 3
4 N C T C A 2 - M 0 4 T C A 3 - M 0 4
Overload RelaysFor Mini Contactors
Direct Mounting
Coil Voltage Codes for Mini Contactors & Control Relays
0.10 - 0.16 TR2 - M0.14A
0.16 - 0.25 TR2 - M0.21A
0.25 - 0.4 TR2 - M0.33A
0.4 - 0.63 TR2 - M0.52A
0.63 - 1 TR2 - M0.82A
1 - 1.6 TR2 - M1.3A
1.6 - 2.5 TR2 - M2.1A 900 1
2.5 - 4 TR2 - M3.3A
4 - 6 TR2 - M5A
5 - 8 TR2 - M6.5A
6 - 9 TR2 - M7.5A
7 - 10 TR2 - M8.5A
9 - 13 TR2 - M11A 1100
12 - 16 TR2 - M14A 1100
With AC Coil With DC Coil
2 0 2 . 2 3 61 N O - T C 1 - M 0 6 1 0 1 N O - T P 1 - M 0 6 1 0
- 1 N C T C 1 - M 0 6 0 1 6 1 0 1 0
- 1 N C T P 1 - M 0 6 0 1 9 3 5
2 0 4 5 . 5 91 N O - T C 1 - M 0 9 1 0 1 N O - T P 1 - M 0 9 1 0
- 1 N C T C 1 - M 0 9 0 1 6 4 5 1 0
- 1 N C T P 1 - M 0 9 0 1 9 7 5
1
2 0 5 . 5 7 . 5 1 21 N O - T C 1 - M 1 2 1 0 1 N O - T P 1 - M 1 2 1 0
- 1 N C T C 1 - M 1 2 0 1 7 0 0 1 0
- 1 N C T P 1 - M 1 2 0 1 1 0 2 0
2 0 7 . 5 1 0 1 61 N O - T C 1 - M 1 6 1 0 1 N O - T P 1 - M 1 6 1 0
- 1 N C T C 1 - M 1 6 0 1 9 0 0 1 0
- 1 N C T P 1 - M 1 6 0 1 1 1 5 0
ReferenceTA7-M0964
MRP( ` )( ` )( ` )( ` )( ` ) 3 3 5
GLOBAL CERTIFICATION
Contactor Voltage
24 48 110 220 415
AC B E F M N
D C B D E D FD MD -
With AC Coil With DC Coil
Relay Range[A]
ReferenceIndependent
MountingKit
MRP( ` )( ` )( ` )( ` )( ` )
Rated Current (Ith)Contact
Configuration Reference MRP (`)(`)(`)(`)(`)Std. Pkg.
(No's)Reference MRP (`)(`)(`)(`)(`)
Std. Pkg.(No's)
Reference MRP (`)(`)(`)(`)(`)Std. Pkg.
(No's)Reference MRP (`)(`)(`)(`)(`)
Std. Pkg.(No's)
AuxiliaryContacts
AuxiliaryContacts
AC3 415VLong Life
kW HP A
AC1Duty
A
MINI CONTACTOR
1 0
Std.Pkg.(No's)
MRP w.e.f. 19th April 201156
ADD-ON-BLOCK
Accessories for Mini ContactorsMechanical Interlocks for Horizontally Mounted
COIL SUPPRESSORELECTRONIC TIMER
AC 24~ 48V TA9-M980/1AC 60~ 127V TA9-M980/2
AC 200~ 240V TA9-M980/3
DC 12~ 24V TA9-M980/4 285 1
DC 30 ~ 72V TA9-M980/5
DC 100 ~ 127 V TA9-M980/6
DC 200~ 250 V TA9-M980/7
Varis
tor
Description Delay Time Voltage Reference MRP (`)(`)(`)(`)(`)
Front ON Delay 0.1~30sec AC/DC TA2-M/ 1N
Mounting OFF Delay 0.1~30sec 24~48V TA2-M/ 1F
Electronic ON Delay 0.1~30sec AC TA3-M/ 2N
Timer OFF Delay 0.1~30sec 100~220V TA3-M/ 2F
1050
TC1-M S 06 TP1- M S 0 6
TC1-M S 0 9 TP1- M S 0 9TC1-M S 1 2 TP1- M S 1 2TC1-M S 1 6 TP1- M S 1 6
T A 9 - M 9 7 8 2 6 0 1
M R P ( ` )( ` )( ` )( ` )( ` )Std.Pkg.
(No ' s )Re fe rence
Use For Contactor
AC DC
Std. Pkg.(No's)
F r o n t 2 N O T A 1 - M2 0
M o u n t e d 1 N O + 1 N C T A 1 - M1 1 1 5 5 10
2 N C T A 1 - M0 2
4 N O T A 1 - M4 0
3 N O + 1 N C T A 1 - M3 1
2 N O + 2 N C T A 1 - M2 2 280 10
1 N O + 3 N C T A 1 - M1 3
4 N C T A 1 - M0 4
S ide 1 N C T A 8 - M01
M o u n t e d 1 N O T A 8 - M10180 10
M R P ( ` )( ` )( ` )( ` )( ` )Refe renceContact
Configuration
MINI CONTACTOR
Description Voltage Reference MRP (`)(`)(`)(`)(`) Std. Pkg.(No's)
MRP w.e.f. 19th April 2011 57
Control Relays - 10A
With AC Coil With DC Coil
2 N O + 2 N C T C A 2 - D N 2 2 T C A 3 - D N 2 21 0 3 N O + 1 N C T C A 2 - D N 3 1 7 6 5 1 T C A 3 - D N 3 1 1 1 2 0 1
4 N O T C A 2 - D N 4 0 T C A 3 - D N 4 0
To speci fy Coi l Vol tage, please refer page no. 56
Power Contactors 3 Pole : Rating 9A ~ 95A
To speci fy Coi l Vol tage, please refer page no. 60
With AC Coil With DC Coil
Re fe renceMRP( ` )( ` )( ` )( ` )( ` )
Std. Pkg.(No ' s )
Re fe renceAuxiliaryContacts
AuxiliaryContacts
AC1Duty
A
AC3 415 VLong Life
kW HP AMRP( ` )( ` )( ` )( ` )( ` )
Std. Pkg.(No ' s )
ContactConfiguration M R P ( ` )( ` )( ` )( ` )( ` )
Std. Pkg.(No ' s )
Re fe rence M R P ( ` )( ` )( ` )( ` )( ` )Std. Pkg.
(No ' s )Re fe rence
Rated Current(Ie)AC15 at 240V
(Amps)
4 5.5 9 1NO - TC1-D0910 NO - TP1-D0910
- 1NC TC1-D0901 690 1
- 1NC TP1-D0901 990 1
5.5 7.5 12 1NO - TC1-D1210 NO - TP1-D1210
- 1NC TC1-D1201 780 1
- 1NC TP1-D1201 1060 1
9 12.5 18 1NO - TC1-D1810 NO - TP1-D1810
- 1NC TC1-D1801 890 1
- 1NC TP1-D1801 1275 1
11 15 22 1NO - TC1-D2210 NO - TP1-D2210
- 1NC TC1-D2201 1015 1
- 1NC TP1-D2201 1725 1
11 15 25 1NO - TC1-D2510 NO - TP1-D2510
- 1NC TC1-D2501 1200 1
- 1NC TP1-D2501 1875 1
15 20 32 1NO - TC1-D3210 NO - TP1-D3210
- 1NC TC1-D3201 2480 1
- 1NC TP1-D3201 3760 1
18.5 25 38 1NO - TC1-D3810 NO - TP1-D3810
- 1NC TC1-D3801 3610 1
- 1NC TP1-D3801 4620 1
22 30 40 1NO 1NC TC1-D4011 3800 1 NO 1NC TP1-D4011 5000 1
22 30 45 1NO 1NC TC1-D4511 POR 1 NO 1NC TP1-D4511 POR 1
25 35 50 1NO 1NC TC1-D5011 4640 1 NO 1NC TP1-D5011 6900 1
37 50 65 1NO 1NC TC1-D6511 6200 1 NO 1NC TP1-D6511 7050 1
37 50 70 1NO 1NC TC1-D7011 POR 1 NO 1NC TP1-D7011 POR 1
45 60 80 1NO 1NC TC1-D8011 7975 1 NO 1NC TP1-D8011 9500 1
45 60 95 1NO 1NC TC1-D9511 9440 - - - - -
25
32
40
50
60
80
125
GLOBAL CERTIFICATIONrobusTa Power ContactorsConforming IS13947-4: IEC60947-4
CONTACTOR
To speci fy Coi l Vol tage, please refer page no. 60
With AC Coil
MRP( ` )( ` )( ` )( ` )( ` )
Std. Pkg.(No ' s )
Re fe rence
AC1Duty
A
AC3 415 VLong Life
kW HP A
4 5.5 9 TC1-D09006 1000
5.5 7.5 12 TC1-D12006 1175 10
11 15 25 TC1-D25006 1950
25
40
Power Contactors 3 Pole 4 NC: Rating 9~25A
100
MRP w.e.f. 19th April 201158
Power Contactors With Dust Cover 3 Pole: Rating 115A ~ 800A
With AC Coil With DC Coil
R e f e r e n c eM R P ( ` )( ` )( ` )( ` )( ` ) S t d . P k g .( N o ' s )
R e f e r e n c e
AC1Duty
A
AC3 415 VLong Life
kW HP A M R P ( ` )( ` )( ` )( ` )( ` ) S t d . P k g .( N o ' s )
To specify Coi l Vol tage, please refer page no. 60 Power Contactors with dust cover 2 Pole var iants avai lable on requests Power Contactors with dust cover rat ing 115~800A are suppl ied factor y assembled complete with No-Volt Coi l and
auxi lar y contact block 2NO+2NC.
With AC Coil
M R P ( ` )( ` )( ` )( ` )( ` ) Std. Pkg. ( N o ' s )Re fe rence
AC1Duty
A
AC3 415 VLong Life
kW HP A
200 59 80 115 LC1FDP115HCA 10950
250 80 110 150 LC1FDP150HCA 18500
275 100 135 185 LC1FDP185HCA 19000
315 110 150 225 LC1FDP225HCA 23000 1
350 140 190 265 LC1FDP265HCA 24400
400 180 220 330 LC1FDP330HCA 32000
500 220 300 400 LC1FDP400HCA 37500
GLOBAL CERTIFICATION
CONTACTOR
With AC Coil
M R P ( ` )( ` )( ` )( ` )( ` ) Std. Pkg. ( N o ' s )Re fe rence
AC1Duty
A
Main PoleConfiguration
25 4 NO TC1DT254Ne
32 4 NO TC1DT324Ne
40 4 NO TC1DT404Ne 40
50 4 NO TC1DT504Ne
60 4 NO TC1DT604Ne
80 4 NO TC1DT804Ne
100 4 NO TC1DT1004Ne 10
125 4 NO TC1DT1254Ne
POR
Hoisting Power Contactors with dust cover 3 Pole : Rating115A ~ 400A
Telecom Contactors 4Pole Rating AC1 25 A~ 125A
N o n S t o c k a b l e i t e m
To specify Coi l Vol tage, please refer page no. 60
200 59 80 115 LC1FDP115A 10650 1 LC1FDP115A 12400 1
250 80 108 150 LC1FDP150A 14300 1 LC1FDP150A 16700 1
275 100 136 185 LC1FDP185A 19500 1 LC1FDP185A 21500 1
275 105 140 200 LC1FDP200A POR 1 LC1FDP200A POR 1
315 110 148 225 LC1FDP225A 21000 1 LC1FDP225A 22800 1
350 140 190 265 LC1FDP265A 25200 1 LC1FDP265A 26600 1
350 150 200 300 LC1FDP300A POR 1 LC1FDP300A POR 1
400 180 240 330 LC1FDP330A 30300 1 LC1FDP330A 32000 1
500 220 300 400 LC1FDP400A 37600 1 LC1FDP400A 38000 1
700 280 380 500 LC1FDP500A 51300 1 LC1FDP500A 57000 1
1000 375 500 630 LC1FDP630A 81000 1 LC1FDP630A 90000 1
1600 425 580 780 LC1FDP780A 140000 1 LC1FDP780A 145000 1
1000 450 610 800 LC1FDP800A 115000 1
MRP w.e.f. 19th April 2011 59
Power Contactors with dust cover 4 Pole : Rating AC1 200A ~ 1600A
To specify Coi l Vol tage, please refer page no. 60
With AC Coil With DC Coil
Re fe renceM R P ( ` )( ` )( ` )( ` )( ` ) Std. Pkg.(No ' s )
Re fe rence
AC1Duty
A
Main PoleConfiguration
M R P ( ` )( ` )( ` )( ` )( ` ) Std. Pkg.(No ' s )
200 4 NO LC1FDP1154 15700 1 LC1FDP1154 20000 1
250 4 NO LC1FDP1504 18000 1 LC1FDP1504 23500 1
275 4 NO LC1FDP1854 27000 1 LC1FDP1854 30200 1
315 4 NO LC1FDP2254 29200 1 LC1FDP2254 33500 1
350 4 NO LC1FDP2654 31700 1 LC1FDP2654 38000 1
400 4 NO LC1FDP3304 39700 1 LC1FDP3304 46000 1
500 4 NO LC1FDP4004 46500 1 LC1FDP4004 55000 1
700 4 NO LC1FDP5004 66500 1 LC1FDP5004 78000 1
1000 4 NO LC1FDP6304 105000 1 LC1FDP6304 109000 1
1600 4 NO LC1FDP7804 220000 1 LC1FDP7804 230000 1
254NO -- TC1-D12004 1045 TP1-D12004 1560
12NO 2NC TC1-D12008 1290
1 TP1-D12008 1970
404NO -- TC1-D25004 1650 TP1-D25004 2950
12NO 2NC TC1-D25008 2150
1 TP1-D25008 3800
604NO -- TC1-D40004 3900 TP1-D40004 4850
2NO 2NC TC1-D40008 61001
TP1-D40008 68001
804NO -- TC1-D65004 6500 TP1-D65004 8400
2NO 2NC TC1-D65008 84001
TP1-D65008 94001
1254NO -- TC1-D80004 8750 TP1-D80004 10500
2NO 2NC TC1-D80008 103501
TP1-D80008 117001
Power Contactors 4 Pole : Rating AC1 25A ~ 125A
To specify Coi l Vol tage, please refer page no. 60
With AC Coil With DC Coil
Re fe renceM R P ( ` )( ` )( ` )( ` )( ` ) Std. Pkg.(No ' s )
Re fe rence
AC1Duty
A
Main PoleConfiguration
M R P ( ` )( ` )( ` )( ` )( ` ) Std. Pkg.(No ' s )
GLOBAL CERTIFICATION
CONTACTOR
N o n S t o c k a b l e i t e m
MRP w.e.f. 19th April 201160
DC Coil Voltage Codes for Contactors 9A~95A & Control Relays
# W ide band Co i l ava i lab le i n 50 Hz on l y
AC Coil Voltage Codes for Contactors 9A~95A & Control Relays
Non-Standard coil Ex t ra MRP @ ̀̀̀̀̀ 100/- per contactor
Contactor Voltage
TCA2-DN / TC1-D 24 48 110 220 240 415
50Hz B5 E5 F5 M5 U5 N5
50/60Hz B7 E7 F7 M7 U7 N7
Contactor Voltage
TCA3-DN/ TP1-D 2 4 4 8 7 2 110 220
Normal Coi l B D E D S D F D M D
Wide band Coi l# B W E W - FW -
AC Coil Voltage Codes for Contactors 115A~780A
AC Coil Voltage Codes for Contactors 115A~780A
C o n t a c t o r Vo l t a g e
T y p e 1 1 0 2 2 0 2 4 0 4 1 5
L C 1 F D P F M U N
How to order:
I) Se lect appl icable Coi l Vol tage requi red for Contactor.
i i ) Complete the code by replacing the
i i i ) To order addi t ional Aux i l ia r y B lock, T imers and otheraccessor ies, p lease refer page 62
Non-Standard coil avai lable on request, ExtraM R P@ `̀̀̀̀ 500 e a c h p e r C o n t a c t o r r a t i n g 1 1 5 # 7 8 0 A
C o n t a c t o r Vo l t a g e
T y p e 2 4 # 4 8 1 1 0 2 2 0
L C 1 F D P B D E D F D M D
# Not available for LC1FDP400, LC1FDP500, LCFDP630 & LC1FDP780
71NO+1NC TC1-D7K11
2NC TC1-D7K02 1600
101NO+1NC TC1-D10K11
2NC TC1-D10K02 1750
12.5 1NO+1NC TC1-D12K11
2NC TC1-D12K02 1850
16.71NO+1NC TC1-D16K11
2NC TC1-D16K02 2400 1
201NO+1NC TC1-D20K11
2NC TC1-D20K02 2600
251NO+1NC TC1-D25K11
2NC TC1-D25K02 3100
33.3 1NO+2NC TC1-D33K12 6150
40 1NO+2NC TC1-D40K12 9500
60 1NO+2NC TC1-D60K12 10850
Capacitor Duty Contactors 3 Pole, AC
ReferencekVAR Rating Auxiliary Contacts M R P ( ` )( ` )( ` )( ` )( ` ) Std. Pkg. ( N o ' s )
AC Coil Voltage robusTa Capacitor Duty Contactors
C o n t a c t o r Vo l t a g eT C 1 - D * * K 2 4 1 1 0 2 2 0 2 4 0 4 1 5
5 0 H z B 5 F 5 M 5 U 5 N 5
5 0 / 6 0 H z B 7 F 7 M 7 U 7 N 7
N o t A v a i l a b l e f o r L C 1 F D P 7 8 0
GLOBAL CERTIFICATION
AC Coil Voltage Codes for Contactor 800A
Contacto r Vol tage
T y p e 1 1 0 / 1 2 7 2 2 0 / 2 4 0 3 8 0 / 4 0 0
LC1-FDP F W M W Q W
robusTa Contactors Coils
CONTACTOR
AC Coil for 4 Pole Telecom Contactor
C o n t a c t o r Vo l t a g eT C 1 - D T * * N e 2 3 0 2 3 5 2 4 0 4 1 5
5 0 H z P C 5 W M N
A l l co i l s codes app l icab le fo r ex t ra w ide band co i l s .
MRP w.e.f. 19th April 2011 61
Thermal Overload Relays Direct Mounting
ReferenceRelay Setting Range
(Amps)
Su i tab le fo rContacto r Ra t ing
(Amps)
Std. Pkg.(No ' s )
Standard PowerRating for 3 Ph. Motor at 415V
HP kW
Indepen-dentMount ing K i t
S td . Pkg. (No ' s )Re fe renceRe lay Type MRP (`)(`)(`)(`)(`)
LR1-F(M)105
LR1-F(M)125
LR1-F160LA9-F702 1145 1
LR1-F200
LR1-F250
LR1-F315LA9-F703 1545 1
LR1-F400
LR1-F500 LA9-F703 1545 1
LR1-F630
Thermal Overload RelaysProtective Shroud for LR1-F105~630 Std. Pkg. (No ' s )Re fe rence
Re lay Se t t ing Range(Amps ) MRP (`)(`)(`)(`)(`)
2.5-4.0 TR6 - F4
4.0-6.3 TR6 - F6.3
6.3-10 TR6 - F10
8.0-12.5 TR6 - F12.5
10-16 TR6 - F16
16-25 TR6 - F25
25-40 TR6 - F40 7900 1
40-63 TR6 - F63
63-100 TR6 - F100
100-160 TR6 - F160
125-200 TR6 - F200
160-250 TR6 - F250
250-400 TR6 - F400
Heavy Duty Overload RelaysIndependent Mounting
robusTa Overload Relay
OVERLOAD RELAY
N o n S t o c k a b l e i t e m
M R P ( ` )( ` )( ` )( ` )( ` )
Direct Mounting
0.10 ~ 0.16 * * TR2-D09301
0.16 ~ 0.25 * * TR2-D09302
0.25 ~ 0.40 * * TR2-D09303
0.40 ~ 0.63 * * TR2-D09304
0.63 ~ 1.00 0.5 0.37 TR2-D09305
1.00 ~ 1.60 0.75 0.55 TR2-D09306
1.25 ~ 2.00 1.0 0.75 TR2-D093X6 9 1050
1.60 ~ 2.50 1.5 1.1 TR2-D09307
2.50 ~ 4.00 2.0 1.5 TR2-D09308
4.00 ~ 6.00 3.0 2.2 TR2-D09310
5.50 ~ 8.00 5 3.7 TR2-D09312
7.00 ~ 10.0 5.5 4 TR2-D09314
9.0 ~ 13.0 7.5 5.5 TR2-D12316 12
12.0 ~ 18.0 12 9 TR2-D18321 18
17.0 ~ 25.0 15 11 TR2-D25322 251140
23.0 ~ 32.0 20 15 TR2-D32353
28.0 ~ 36.0 20 18 TR2-D3235532 1740
23.0 ~ 32.0 20 15 TR2-D40353
30.0 ~ 40.0 30 22 TR2-D4035540 1875
37.0 ~ 50.0 35 25 TR2-D65357 2470
48.0 ~ 65.0 40 30 TR2-D653596555.0 ~ 70.0 50 37 TR2-D65361
2950
63.0 ~ 80.0 60 45 TR2-D80363 80 3000
80.0 ~ 93.0 65 49 TR2-D95365 95 3200
Independent Mounting
65 ~ 105 75 55 LR1-F105
80 ~ 125 80 59 LR1-F125
100 ~ 160 110 80 LR1-F160 5520 1
125 ~ 200 135 100 LR1-F200
160 ~ 250 175 129 LR1-F250
200 ~ 315 220 160 LR1-F315
250 ~ 400 270 200 LR1-F400
315 ~ 500 350 257 LR1-F500
400 ~ 630 480 355 LR1-F630
7000 1
500 ~ 800 580 425 LR1-F800
630 ~ 1000 680 500 LR1-F100018900 1
TA7-D3264` 270
TA7-D4064` 910
1
1
1
ReferenceTA7-D0964MRP `190
MRP w.e.f. 19th April 201162
Std. Pkg.(No ' s )
Re fe renceContact
Conf igurat ionMRP (`)(`)(`)(`)(`)
1 NO TA1-DN10*
1 NC TA1-DN01100 10
2 NO TA1-DN20
1 NO+1 NC TA1-DN11 190 20
2 NC TA1-DN02
Front Mounted 4 NO TA1-DN40
3 NO+1 NC TA1-DN31
2 NO+2 NC TA1-DN22 295 20
1 NO+3 NC TA1-DN13
4 NC TA1-DN04
Side Mounted1 NO+1 NC TA8-DN11**
2 NO TA8-DN20295 10
Add-On Block for Contactor Rating 9~800A
Std. Pkg.(No ' s )
Re fe renceContact
Conf igurat ionMRP( ` )( ` )( ` )( ` )( ` )
ON delay 1 NO+1 NC TA2-DT0 0.1...3s
ON delay 1 NO+1 NC TA2-DT2 0.1...30s 1100 10
ON delay 1 NO+1 NC TA2-DT4 10...180s
OFF delay 1 NO+1 NC TA3-DR0 0.1...3s
OFF delay 1 NO+1 NC TA3-DR2 0.1...30s 1100 10
OFF delay 1 NO+1 NC TA3-DR4 10...180s
Star Delta 1 NO+1 NC TA2-DS2 1...30s 1300 10
Pneumatic Timer Block - Front Mounted
Std. Pkg.(No ' s )
Re fe renceDescr ipt ionMRP( ` )( ` )( ` )( ` )( ` )
24~48VAC/DC TA9AMOV980E 375
110~240V AC/DC TA9AMOV980U 37510
24~48V AC TA9RC980E 375
110~240V AC TA9RC980U 375 10
380~440V AC TA9RC980N 375
Vol tage Rat ings
Varistor (AC/DC)Clip-on mounting
RC Circuit (AC)Clip-on mounting
Coil Surge Suppressor for Contactor 9~95A
Std. Pkg.(No ' s )
Re fe rence*Use fo r Con tac to r
ACMRP (`)(`)(`)(`)(`)
TCA2-DN
TC1-D09
TC1-D12TX1-D2 355 20
TC1-D18
TC1-D25
TC1-D32TX1-D4 480 10
TC1-D40
TC1-D50
TC1-D63 TX1-D6 960 10
TC1-D80
TC1-D95
AC Coils Control Relay & Contactor 9~95A
Std. Pkg.(No ' s )
Re fe rence*Use fo r Con tac to r
DCMRP (`)(`)(`)(`)(`)
TCA3 - DN
TP1 - D09
TP1 - D12TX4-D2 TX5-D2 495 1
TP1 - D18
TP1 - D25
TP1 - D32TX4-D4 TX5-D4 645 1
TP1 - D40
TP1 - D50 TX4-D40 TX5-D40 1200 1
TP1 - D65
TP1 - D80 TX4-D80 TX5-D80 3000 1
DC Coils Control Relay & Contactor 9~80A
Std. Pkg.(No ' s )
Re fe rence*Use fo r Con tac to r
MRP (`)(`)(`)(`)(`)
TC1-D09 TP1-D09
TC1-D12 TP1-D12
TC1-D18 TP1-D18 ELA9-D09978
TC1-D25 TP1-D25
TC1-D32 TP1-D32 10
TC1-D40 TP1-D40
TC1-D50 TP1-D50 ELA9-D50978
TC1-D65 TP1-D65
TC1-D80 TP1-D80
TC1-D95 -ELA9-D80978
Electrical & Mechanical Interlocks - Horizontal Mounted
AC DC
Complete the code for Spare Coi l by indicat ing the Coi lVol tage requi red af ter the reference
*Please refer page no. 60 for Coi l Vol tage avai lable
ACCESSORIES for robusTa Contactors
ACCESSORIES - CONTACTOR
Std. Pkg.(No ' s )
Re fe rence*Use fo r Con tac to r
MRP (`)(`)(`)(`)(`)
TC1-D09 TP1-D09
TC1-D12 TP1-D12
TC1-D18 TP1-D18 LA9-D09978 300 10
TC1-D25 TP1-D25
TC1-D32 TP1-D32
TC1-D40 TP1-D40
TC1-D50 TP1-D50 LA9-D50978 560 10
TC1-D65 TP1-D65
TC1-D80 TP1-D80
TC1-D95 -LA9-D80978 830 10
Mechanical Interlocks - Horizontal Mounted
AC DC
POR
* Suitable for robusTa Contactor rating 25~95A only.
** Suitable for robusTa Contactor rating 9~95A only.
MRP w.e.f. 19th April 2011 63
240VContacto rMRP( ` )( ` )( ` )( ` )( ` )
LC1-FDP115HCLX9FF110V LX9FF220V LX9FF240V - 2600
LC1-FDP150HC
LC1-F185LX9FG110V LX9FG220V LX9FG240V - 2950
LC1-F225
LC1-F265ALX9FH1102V LX9FH2202V LX9FH2402V - 3300
LC1-F330A
LC1-F400A LX9FJ925 LX9FJ931 LX9FJ932 LX9FJ936 9000
AC Coils for Hoisting Power Contactor
415V220V110V
NOTE: The above Coil includes rectifier price. Standard Packing 1 No.
MRP( ` )( ` )( ` )( ` )( ` )
LC1-F115LX1FF-110V LX1FF-220V LX1FF-240V LX1FF-415V 1750
LC1-F150
LC1-F185LX1FG-110V LX1FG-220V LX1FG-240V LX1FG-415V 2750
LC1-F225
LC1-F265ALX1FH-1102V LX1FH-2202V LX1FH-2402V LX1FH-4152V 2900
LC1-F330A
LC1-F400A LX1FJ-110V LX1FJ-220V LX1FJ-240V LX1FJ-415V 5800
LC1-F500A LX1FK-110V LX1FK-220V LX1FK-240V LX1FK-415V 9200
LC1-F630A LX1FL-110V LX1FL-220V LX1FL-240V LX1FL-415V 11330
LC1-F780A LX1FX-110V LX1FX-220V LX1FX-240V LX1FX-415V 19800
AC Coils for Contactors Rating 115~780A
* AC Coils will be suitable for 50Hz only.NOTE: The above Coil includes rectifier price. Std. Packing 1 Nos.
240VContacto r 415V220V110V
Vertically Mounted
LC1-FDP115A
LC1-FDP150ALA9-FF4F 1800 1
LC1-FDP185A
LC1-FDP225ALA9-FG4G 2100 1
LC1-FDP265A
LC1-FDP330ALA9-FH4H
LC1-FDP400A LA9-FJ4J
LC1-FDP500A LA9-FK4K
LC1-FDP5004/LC1-F630A LA9-FL4L
2500 1
LC1-FDP780A LA9-FX970 18000 1
Horizontally Mounted
LC1-FDP115A
LC1-FDP150ALA9-FF970 1400 1
LC1-FDP185A
LC1-FDP225ALA9-FG970 1800 1
LC1-FDP265A
LC1-FDP330A LA9-FJ970 2000 1
LC1-FDP400A
LC1-FDP500A
LC1-FDP5004/LC1-F630A LA9-FL970 2150 1
Mechanical Interlocks for Contactor 115~630AVertically / Horizontally Mounted
Contacto r MRP (`)(`)(`)(`)(`)Refe rence Std. Pkg.(No ' s )
24VContacto rMRP( ` )( ` )( ` )( ` )( ` )
LC1-F115LX4FF-110V LX4FF-220V LX4FF-24V LX4FF-48V 5400
LC1-F150
LC1-F185LX4FG-110V LX4FG-220V LX4FG-24V LX4FG-48V 8000
LC1-F225
LC1-F265ALX4FH-110V LX4FH-220V LX4FH-24V LX4FH-48V 9800
LC1-F330A
LC1-F400A LX4FJ-110V LX4FJ-220V Not Available LX4FJ-48V 13400
LC1-F500A LX4FK-110V LX4FK-220V Not Available LX4FK-48V 13400
LC1-F630A LX4FL-110V LX4FL-220V Not Available LX4FL-48V 15180
LC1-F780A - - - - 28400
DC Coils for Contactors Rating 115~780A
48V220V110V
NOTE: The above Coil includes rectifier price. Std. Packing 1 Nos.
Fo r Con t ro l Re layContacto r
Std. Pkg.(No ' s )
For 3 Pole
TCA2-DN40, TCA3-DN40 TA5-DN40 TA5-DN40 DC
TCA2-DN31, TCA3-DN31 TA5-DN31 TA5-DN31 DC
TCA2-DN22, TCA3-DN22 TA5-DN22 TA5-DN22 DC
TC1-D0910, TP1-D0910 TA5-D0910 TA5-D0910 DC 650 1
TC1-D0901, TP1-D0901 TA5-D0901 TA5-D0901 DC
TC1-D1210, TP1-D1210 TA5-D1210 TA5-D1210 DC
TC1-D1201, TP1-D1201 TA5-D1201 TA5-D1201 DC
TC1-D1810, TP1-D1810 TA5-D1810 TA5-D1810 DC
TC1-D1801, TP1-D1801 TA5-D1801 TA5-D1801 DC750 1
TC1-D2210, TP1-D2210 TA5-D2210 TA5-D2210 DC
TC1-D2201, TP1-D2201 TA5-D2201 TA5-D2201 DC930 1
TC1-D2510, TP1-D2510 TA5-D2510 TA5-D2510 DC
TC1-D2501, TP1-D2501 TA5-D2501 TA5-D2501 DC980 1
TC1-D3210, TP1-D3210 TA5-D3210 TA5-D3210 DC
TC1-D3201, TP1-D3201 TA5-D3201 TA5-D3201 DC1925 1
TC1-D3810, TP1-D3810 TA5-D3810 TA5-D3810 DC
TC1-D3801, TP1-D3801 TA5-D3801 TA5-D3801 DC2815 1
TC1-D4011, TP1-D4011 TA5-D4011 TA5-D4011 DC 2970 1
TC1-D5011, TP1-D5011 TA5-D5011 TA5-D5011 DC 3655 1
TC1-D6511, TP1-D6511 TA5-D6511 TA5-D6511 DC 4865 1
TC1-D8011, TP1-D8011 TA5-D8011 TA5-D8011 DC 6020 1
TC1-D9511 TA5-D9511 - 7070 1
For 4 Pole
TC1-D09004, TP1-D09004 TA5-D09004 TA5-D09004DC 780 1
TC1-D09008, TP1-D09008 TA5-D09008 TA5-D09008DC 875 1
TC1-D12004, TP1-D12004 TA5-D12004 TA5-D12004DC 820 1
TC1-D12008, TP1-D12008 TA5-D12008 TA5-D12008DC 1005 1
TC1-D25004, TP1-D25004 TA5-D25004 TA5-D25004DC 1460 1
TC1-D25008, TP1-D25008 TA5-D25008 TA5-D25008DC 1735 1
TC1-D40004, TP1-D40004 TA5-D40004 TA5-D40004DC 3300 1
TC1-D40008, TP1-D40008 TA5-D40008 TA5-D40008DC 4265 1
TC1-D65004, TP1-D65004 TA5-D65004 TA5-D65004DC 5660 1
TC1-D65008, TP1-D65008 TA5-D65008 TA5-D65008DC 6700 1
TC1-D80004, TP1-D80004 TA5-D80004 TA5-D80004DC 6800 1
Top Housing for 3P/4P Contactors
M.R.P.( ` )( ` )( ` )( ` )( ` )AC DC
Refe rence
CONTACTOR
N o n S t o c k a b l e i t e m
MRP w.e.f. 19th April 201164
Std. Pkg.(Nos.)
LC1-FDP115A LA5-FF431 (F115) 5950 1
LC1-FDP150A LA5-FF431 (F150) 6550 1
LC1-FDP185A LA5-FG431 (F185) 12500 1
LC1-FDP225A LA5-FG431 (F225) 13600 1
LC1-FDP265A LA5-FH431 (F265) 13900 1
LC1-FDP330A LA5-F400803 (F330) 20100 1
LC1-FDP400A LA5-F400803 (F400) 20850 1
LC1-FDP500A LA5-F500803 (F500) 28900 1
LC1-FDP630A LA5-F630803 (F630) 41000 1
LC1-F780A LA5-F780801 (F780)* 26000 1
For 3P Hoisting Power Contactors #
LC1-FDP115HCA
LC1-FDP150HCA
LC1-FDP185HCA
LC1-FDP225HCA
LC1-FDP265HCA
LC1-FDP330HCA
LC1-FDP400HCA
Main Contact for 3P Contactors rating 115~780A
Contacto rMRP( ` )( ` )( ` )( ` )( ` )
Refe rence
LA5-FF431 (F115)HD 6100 1
LA5-FF431 (F150)HD 7300 1
LA5-FG431 (F185)HD 14100 1
LA5-FG431 (F225)HD 14700 1
LA5-FH431 (F265)HD 16300 1
LA5-F400803 (F330)HD 22200 1
LA5-F400803 (F400)HD 23500 1
Std. Pkg.(Nos.)
LC1-FDP115A LA5-F11550 1630 1
LC1-FDP150A LA5-F15050 1630 1
LC1-FDP185A LA5-F18550 1990 1
LC1-FDP225A LA5-F22550 2100 1
LC1-FDP265A LA5-F26550 2330 1
LC1-FDP330A LA5-F33050 3200 1
LC1-FDP400A LA5-F40050 3440 1
LC1-FDP500A LA5-F50050 3730 1
LC1-FDP630A LA5-F63050 9035 1
LC1-FDP780A LA5-F780150* 6575 1
For 3P Hoisting Contactors with Dust Cover
LC1-FDP115HCA
LC1-FDP150HCA
LC1-FDP185HCA
LC1-FDP225HCA
LC1-FDP265HCA
LC1-FDP330HCA
LC1-FDP400HCA
Arc Chamber 3P
Contacto rMRP( ` )( ` )( ` )( ` )( ` )
Refe rence
LA5-FDP11550HD 1670 1
LA5-FDP15050HD 1850 1
LA5-FDP18550HD 2380 1
LA5-FDP22550HD 2485 1
LA5-FDP26550HD 2780 1
LA5-FDP33050HD 3690 1
LA5-FDP40050HD 3840 1
Std. Pkg.(Nos.)
LC1-FDP1154A LA5-FF441 (F1154) 7400 1
LC1-FDP1504A LA5-FF441 (F1504) 10290 1
LC1-FDP1854A LA5-FF441 (F1854) 18325 1
LC1-FDP2254A LA5-FF441 (F2254) 19100 1
LC1-FDP2654A LA5-FH431 (F2654) 20300 1
LC1-FDP3304A LA5-F400803 (F3304) 24775 1
LC1-FDP4004A LA5-F400803 (F4004) 28275 1
LC1-FDP5004A LA5-F500804 (F5004) 43800 1
LC1-FDP6304A LA5-F630804 (F6304) 56000 1
LC1-FDP7804A LA5-F780801 (F780)** 25000 1
Main Contact Sets for 4P Power Contactors #rating 115~780A
Contacto rMRP( ` )( ` )( ` )( ` )( ` )Refe rence
Std. Pkg.(Nos.)
LC1-FDP1154A LA5-FF441 (F1154) 7245 1
LC1-FDP115A LA5-F115450 2020 1
LC1-FDP150A LA5-F150450 2090 1
LC1-FDP185A LA5-F185450 2910 1
LC1-FDP225A LA5-F225450 3030 1
LC1-FDP265A LA5-F265450 3600 1
LC1-FDP330A LA5-F330450 3820 1
LC1-FDP400A LA5-F400450 4770 1
LC1-FDP500A LA5-F500450 5475 1
LC1-FDP630A LA5-F630450 13975 1
LC1-FDP780A LA5-F780150* 6570 1
Arc Chamber 4P
Contacto rMRP( ` )( ` )( ` )( ` )( ` )Refe rence
# Main Contacts set per pole includes (2 Fixed Contacts & Moving Contact, 2Deflectors, 1 Backplate, Fixing Screws and Washers).
* Main Contacts are for one pole only. (Set of two) Order 3 Nos for 3 poleContactors & 4 Nos for 4 pole Contactors.
**Set of Main Contacts provided is 1 set of 2 blocks for one pole.
# Main Contacts set per pole includes (2 Fixed Contacts & Moving Contact, 2Deflectors, 1 Backplate, Fixing Screws and Washers).
* Main Contacts are for one pole only. (Set of two) Order 3 Nos for 3 poleContactors & 4 Nos for 4 pole Contactors.
**Set of Main Contacts provided is 1 set of 2 blocks for one pole.
CONTACTOR
Star Delta Timer ,
Range 0 ~ 30 Sec,250~440V ACTCET030SD415VAC 1115 1
Electronic Timer
Descr ipt ion M R P ( ` )( ` )( ` )( ` )( ` )Refe renceStd. Pkg.
(Nos.)
MRP w.e.f. 19th April 2011 65
Control Relays 10 Amps
Contact A.C. MRP Std. Pkg.Arrangement Reference ( ` )( ` )( ` )( ` )( ` ) (No's)
2 N O + 2 N C C A 2 - D N 1 2 2 9 A 6 0
3 N O + 1 N C C A 2 - D N 1 3 1 9 A 6 0 7 5 0 1
4 N O C A 2 - D N 1 4 0 A 6 0
D Range Contactors & Overload Relays
Power Contactors
AC Coil Voltage Codes for D Range Contactors ( Standard )
Contactor Voltage
24 48 110* 220* 240* 415*
LC1-D B E F M U N
* W i d e b a n d C o i l s
Please specify Coil Voltage.
Thermal Overload Relays Type LR1Independent Mounting
Relay Setting Std. Power
Reference MRP (`)`)`)`)`)
Std.Range Rating for 3 Ph. Pkg.
A Motor at 415V (No's)H P kW
66 .0 to 80 .0 6 0 4 5 L R 1 - D 8 0 3 6 3 2 9 6 0 1
* There is no standard power rating for these motors. Select the overload relayin relation to the full load current.
Thermal Overload Relays Type LR1Direct Mounting
Relay Std. Power Reference Independent Std.Setting Rating for 3 Ph. Mounting PkgRange Motor at 415V Ki t (No's)
A H P kW
0 . 1 0 - 0 . 1 6 * * LR1 -D09301
0 . 1 6 - 0 . 2 5 * * LR1 -D09302
0 . 2 5 - 0 . 4 0 * * LR1 -D09303
0 . 4 0 - 0 . 6 3 * * LR1 -D09304
0 . 6 3 - 1 . 0 0 0 .50 0 .37 LR1 -D09305
1 . 0 0 - 1 . 6 0 0 .75 0 .55 LR1 -D09306
1 . 6 0 - 2 . 5 0 1 .50 1 .10 LR1 -D09307
2 . 5 0 - 4 . 0 0 2 .00 1 .50 LR1 -D09308
4 . 0 0 - 6 . 0 0 3 .00 2 .20 LR1 -D09310
5 . 5 0 - 8 . 0 0 5 .00 3 .70 LR1 -D09312
7 . 0 0 - 1 0 . 0 5 .50 4 .00 LR1 -D09314
1 0 . 0 - 1 3 . 0 7 .50 5 .50 LR1 -D12316
1 3 . 0 - 1 8 . 0 12 .00 9 .00 LR1 -D16321
1 8 . 0 - 2 5 . 0 15 .00 11 .00 LR1 -D253221 1 0 0
2 3 . 0 - 3 2 . 0 20 .00 15 .00 LR1 -D32353
2 8 . 0 - 4 0 . 0 20 .00 15 .00 LR1 -D323551 5 2 0 1
2 3 . 0 - 3 2 . 0 20 .00 15 .00 LR1 -D40353
3 0 . 0 - 4 0 . 0 30 .00 22 .00 LR1 -D403551 8 1 0
3 8 . 0 - 5 0 . 0 35 .00 25 .00 LR1 -D63357 2 2 0 0
4 8 . 0 - 5 7 . 0 40 .00 30 .00 LR1 -D63359 2 7 4 0
5 7 . 0 - 6 6 . 0 50 .00 37 .00 LR1 -D63361 2 8 6 5
ReferenceLA7-D0964MRP `̀̀̀̀ 155
R e f e r e n c eL A 7 - D 3 2 6 4MRP `̀̀̀̀235
ReferenceLA7-D4064MRP `̀̀̀̀ 340
GLOBAL CERTIFICATION
D RANGE CONTACTOR
19 8 5
1
3 Pole, AC
2 5 4 5 . 5 91NO - L C 1 - D 0 9 3 A 6 0
- 1NC L C 1 - D 0 9 9 A 6 0665 1
2 5 5 . 5 7 . 5 1 21NO - L C 1 - D 1 2 3 A 6 0
- 1NC L C 1 - D 1 2 9 A 6 0740 1
3 2 9 1 2 . 5 1 61NO - L C 1 - D 1 7 3 A 6 0
- 1NC L C 1 - D 1 7 9 A 6 0850 1
4 0 1 1 1 5 2 51NO - L C 1 - D 2 5 3 A 6 0
- 1NC L C 1 - D 2 5 9 A 6 01170 1
5 0 1 5 2 0 3 21NO - L C 1 - D 3 2 3 A 6 0
- 1NC L C 1 - D 3 2 9 A 6 02420 1
6 0 2 2 3 0 4 0 1NO 1NC L C 1 - D 4 0 3 A 6 0 3700 1
8 0 2 5 3 5 5 0 1NO 1NC L C 1 - D 5 0 3 A 6 0 4600 1
8 0 3 7 5 0 6 3 1NO 1NC L C 1 - D 6 3 3 A 6 0 6000 1
125 4 5 6 0 8 0 1NO 1NC L C 1 - D 8 0 3 A 6 0 7875 1
AC1Duty
A
AC3 415VLong Life
kW HP A
AuxiliaryContacts
ReferenceMRP( ` )( ` )( ` )( ` )( ` )
Std.Pkg.(No's)
Definite Purpose Contactor
S i n g l e P o l e ( W i t h o u t S h u n t )
2 5 3 0 T C D P 2 5 1 * 400
3 0 4 0 T C D P 3 0 1 * 450 1
4 0 5 0 T C D P 4 0 1 * 475
S i n g l e P o l e ( W i t h S h u n t )
2 5 3 0 T C D P 2 5 1 S * 450
3 0 4 0 T C D P 3 0 1 S * 500 1
4 0 5 0 T C D P 4 0 1 S * 525
T w o P o l e
2 0 3 0 T C D P 2 0 2 * 500
3 0 4 0 T C D P 3 0 2 * 5251
4 0 5 0 T C D P 4 0 2 * 600
2 0 3 0 T C D P 2 0 3 * 700
FLAResistive
AMP RatingProduct Reference
MRP( ` )( ` )( ` )( ` )( ` )
Std.Pkg.(No's)
AC Coil Voltage Codes for D Range Contactors ( Non - Standard )
Contactor V o l t a g e
42 360 380
LC1-D D U W Q
For non- standard Coil Voltage, please add ` 100/- in the list price.
AC Coil Voltage Codes for Definite Purpose Contactors
Vol tage 24VAC 110VAC 240VAC
5 0 H z B 5 G 5 U 5
6 0 H z B 6 G 6 U 6
MRP( ` )( ` )( ` )( ` )( ` )
MRP w.e.f. 19th April 201166
AC Coil Voltage Codes for D Range ContactorsAC ( Standard )
Top Housing 3PFor Control Relay/
ReferenceStd.
Contactor MRP (`)(`)(`)(`)(`) Pkg.AC (No's)CA2-DN140 LA5-DN140
CA2-DN1319 LA5-DN1319
CA2-DN1229 LA5-DN1229 635 1
LC1-D093 LA5-D093
LC1-D099 LA5-D099
LC1-D123 LA5-D123
LC1-D129 LA5-D129 710 1
LC1-D173 LA5-D173
LC1-D179 LA5-D179 775 1
LC1-D253 LA5-D253
LC1-D259 LA5-D2591030 1
LC1-D323 LA5-D323
LC1-D329 LA5-D329 2140 1
LC1-D403 LA5-D403 3200 1
LC1-D503 LA5-D503 4000 1
LC1-D633 LA5-D633 5200 1
LC1-D803 LA5-D803 6800 1
C A 2 - D N 1L C 1 - D 0 9
L X 1 - D 0 9 3 3 0 1 5L C 1 - D 1 2L C 1 - D 1 7L C 1 - D 2 5L C 1 - D 3 2
L X 1 - D 2 5 4 9 0 1 0
L C 1 - D 4 0L C 1 - D 5 0 * *L C 1 - D 6 3L C 1 - D 8 0 * *
L X 1 - D 4 0 9 3 5 1
Please specify Coil Voltage by indicating the Coil Voltage required.** Spare Moulded Base for these Coils has Product code LA7-D40 and unit price
is `̀̀̀̀ 135
ACCESSORIES for D Range Contactors
Add-on-BlocksFor D Range Contactors
* This Auxiliary Contact can be used with Contactors.
# Consisting of 1 NO+1 NC make before break contacts.
SPARES
D Range Mechanical InterlocksHorizontally Mounted
Use for ContactorReference
MRP Std. Pkg.AC ( `̀̀̀̀ ) (No's)
LC1-D09L C 1 - D 1 2L C 1 - D 1 7 L A 9 - D 0 9 9 7 8 3 0 0 1 0L C 1 - D 2 5L C 1 - D 3 2L C 1 - D 4 0L C 1 - D 5 0 L A 9 - D 5 0 9 7 8 5 6 0 1 0L C 1 - D 6 3L C 1 - D 8 0 L A 9 - D 8 0 9 7 8 8 3 0 1 0
Coil Suppressor
Description ReferenceMRP Std. Pkg.( `̀̀̀̀ ) (No's)
For mounting across coil ofc o n t a c t o r u p t o 8 0 A m p , w i t h
L A 9 - D 0 9 9 8 0 3 0 0 1 0R C n e t w o r k s u i t a b l ef o r < 2 5 0 V A C & < 4 0 0 V A C
Replace by voltage code AC Not suitable for DC control relay & DC Contactor
Mechanical Latching Blocks
AC Coil Voltage Codes (Standard)
For Mechanical Voltage
Latching Block 24 48 110 220 240 380 415/440
L A 6 - D K 0 1 B E F M U Q N
DescriptionReference
MRP Std. Pkg.For Contractors / Control ( `̀̀̀̀ ) (No's)Relays Type
C A 2 - D N 1L C 1 - D 0 9 , L C 1 - D 1 2 L A 6 - D K 0 1 1450 1 0L C 1 - D 1 7 , L C 1 - D 2 5 , L C 1 - D 3 2
DC Coil Voltage Codes (Standard)Add-on Starting Switch
Description Reference M R P ( ` )( ` )( ` )( ` )( ` )Std. Pkg.
(No's)
N. O start ing S witch suitablefor direct mounting on Control LA9-D09906 110 1 0R elays & Contactors
For Mechanical Voltage
Latching Block 24 48 72 110 220
L A 6 - D K 0 1 B E E N F M
Addi t ional 2 N O LA1 - D 20
1 N O + 1 N C LA1 - D 11 190 20
2 N C LA1 - D 02
4 N O LA1 - D 40
3 N O + 1 N C LA1 - D 31
2 N O + 2 N C L A 1 - D 2 2 * 295 2 0
1 N O + 3 N C LA1 - D 13
4 N C LA1 - D 04
Overlapping2 N O + 2 N C LA1-D1111# 530 10A u x . C o n t a c t s
Use for ContactorReference
MRP Std. Pkg.AC (Standard) ( `̀̀̀̀ ) (No's)
ContactConfiguration
Std. Pkg.(No's)
ReferenceMRP( `̀̀̀̀ )
I n s tan taneous
Aux.Contact
B locks
F rontMounted
F rontMounted
CONTACTOR
MRP w.e.f. 19th April 2011 67
2 & 4 POLE CONTACTOR
AC1 AC3 220V ACDuty
KW HP A
3 2 3 . 8 5 2 0 A C 2 - D 2 0 2 6 5 05
4 0 4 . 8 6 2 5 A C 2 - D 2 5 2 8 2 0
Contactor - 2 Pole AC
Thermal Overload Relays 2 Pole type LR7D - Direct Mounting
1.60~2.50 LR7-D09207 520
2.50~4.00 LR7-D09208 520
4.00~6.00 LR7-D09210 520
5.50~8.00 LR7-D09212 520
7.00~10.0 LR7-D09214 520 1
10.0~13.0 LR7-D12216 520
13.0~18.0 LR7-D16221 590
18.0~25.0 LR7-D25222 590
AC Coil Voltage Codes (Standard) for 2 Pole Contactors
* Wide band Coils Please specify Coil Voltage.
Contactor 2P Voltage
2 2 0 * 2 2 0 / 2 4 0* 3 8 0 / 4 1 5*
AC2-D2/D3/D4 M 5 W M U Q N
Relay Setting Range(Amp)
MRP (`)(`)(`)(`)(`)Reference
MRP (`(`(`(`(`)))))Reference
Std. Pkg.(No's)
AC3,415V Main Poles Reference MRP Std.Configuration ( `̀̀̀̀ ) Pkg.
kW HP A (No's)
7 . 5 1 0 2 0 4 N O T C 1 D X 2 0 4 1 1 6 5
1 1 1 5 2 5 4 N O T C 1 D X 2 5 4 1 6 0 0
Contactors - 4 Pole, AC
5
ACCESSORIES - Coil Voltage Codes for 2Pole Contactors
AX1D2 MU 220/240V, 50Hz 200
AX1D2 M 220V, 50Hz 200 5
AX1D2 QN 380/415V, 50Hz 200
Contact Kit for 2 Pole Contactor
AC5D202 20A Contact Kit, 2-Pole 2401
AC5D252 25A Contact Kit, 2-Pole 505
2 N O L A 1 - D 2 0 A1 N O + 1 N C L A 1 - D 1 1 A 140 2 0
2 N C L A 1 - D 0 2 A
Add-on-Blocks for 2 Pole Contactors
Reference MRP (`)(`)(`)(`)(`)Coil Voltage
DescriptionReference MRP (`)(`)(`)(`)(`)
DescriptionContact
Configuration ReferenceMRP( ` )( ` )( ` )( ` )( ` )
Std. Pkg.(No's)
Std.Pkg.
(No ' s )
AC Coil Voltage Codes (Standard) for 4 Pole Contactors
Wide band Coils Please specify Coil Voltage.
Contactor 4P Voltage220 380 415
TC1-DX204/254 M Q N
TX1DX20 220/380/415 220 1
Contact Kit for 4 Pole Contactor
TA5DX204 20A Contact Kit, 4-Pole 580
TA5DX254 25A Contact Kit, 4-Pole 940
TA5-DX204-1P 20A 4P Contactor 1P kit 180 1
TA5-DX254-1P 25A 4P Contactor 1P kit 280
F ron t moun tedA u x . c o n t a c t B l o c k
NO+1 NC T A 1 - D N 1 1 A 140 2 0
Add-on-Blocks for 4 Pole Contactors
Reference MRP (`)(`)(`)(`)(`)Coil Voltage
DescriptionReference Std. Pkg. (No's)
DescriptionContact
Configuration ReferenceMRP( ` )( ` )( ` )( ` )( ` )
Std. Pkg. (No's)
Std.Pkg.
(No ' s )
ACCESSORIES - Coil Voltage Codes for 4 Pole Contactors
Mechanical Interlock for 4 Pole ContactorsDescription Reference MRP (`)(`)(`)(`)(`) Std. Pkg.
(No ' s )
F ron t moun tedA u x . c o n t a c t B l o c k
H o r i z o n t a l M o u n t e d LA9-D09978 300 1 0Mechan ica l I n te r lock ELA9-D09978 350
Anmol Motor Starters for Agri Segment
0.37 0.50 4.0~6.0 BE1-ASA2025MU210
0.55 0.75 5.5~8.0 BE1-ASA2025MU2121000 6
0.75 1.00 7.0~10.0 BE1-ASA2025MU214
1.1 1.50 10.0~13.0 BE1-ASA2025MU216
1.5 2.00 13.0~18.0 BE1-ASA2525MU221
1200 6
2.2 3.00 18.0~25.0 BE1-ASA2525MU222
Single Phase DOL Starter With 2P Contactor & 2P OLR type LR7DStd. Power Rating forSingle Phase Motor
at 220V AC MRP (`)(`)(`)(`)(`)Complete Unit
ReferenceKW HP
RelayRange(Amp)
Std.Pkg.
(No ' s )
MRP ( ` )( ` )( ` )( ` )( ` )
Std. Pkg.(No's)
Std. Pkg. (No's)
MRP w.e.f. 19th April 201168
B N 1 - D X M 2 0 4 3 0 7 1 . 6 - 2 . 5 1 4 7 5
B N 1 - D X M 2 0 4 3 0 8 2 . 5 - 4 . 0 1 4 7 5
B N 1 - D X M 2 0 4 3 1 0 4 . 0 - 6 . 0 1 4 7 5
B N 1 - D X M 2 0 4 3 1 2 5 . 5 - 8 . 0 1 4 7 5
B N 1 - D X M 2 0 4 3 1 4 7 - 1 0 1 4 7 5 1 2
B N 1 - D X M 2 0 4 3 1 6 1 0 - 1 3 1 4 7 5
B N 1 - D X M 2 0 4 3 2 1 1 3 - 1 8 1 5 8 0
B N 1 - D X M 2 5 4 3 2 1 H 1 3 - 1 8 1 6 9 0
B N 1 - D X M 2 5 4 3 2 2 1 8 - 2 5 1 6 9 0
Anmol Motor StartersWith 4 Pole Contactor type TC1-DX & Overload Relay LR3DM
DOL Starter in Open Execution
Std.Pkg.
(No ' s )Re fe rence
Relay Range(Amps )
M R P ( `̀̀̀̀ )
B E 1 - D X M 2 0 4 3 0 7 1 . 6 - 2 . 5 1 5 3 5
B E 1 - D X M 2 0 4 3 0 8 2 . 5 - 4 . 0 1 5 3 5
B E 1 - D X M 2 0 4 3 1 0 4 . 0 - 6 . 0 1 5 3 5
B E 1 - D X M 2 0 4 3 1 2 5 . 5 - 8 . 0 1 5 3 5
B E 1 - D X M 2 0 4 3 1 4 7 - 1 0 1 5 3 5 1 2
B E 1 - D X M 2 0 4 3 1 6 1 0 - 1 3 1 5 3 5
B E 1 - D X M 2 0 4 3 2 1 1 3 - 1 8 1 6 4 0
B E 1 - D X M 2 5 4 3 2 1 H 1 3 - 1 8 1 7 5 0
B E 1 - D X M 2 5 4 3 2 2 1 8 - 2 5 1 7 5 0
Std.Pkg.
(No ' s )Re fe rence
Relay RangeAmps
M R P ( `̀̀̀̀ )
DOL Starter in S.S Enclosure
Single Phase SPCU Standard Model With 2Pole Contactor & 2Pole Overload Relay LR7DSubmersible Pump Control Unit
0.37 0.50 4.0~6.0 25 80/100 BE1-SSA2025MU210
0.55 0.75 5.5~8.0 36 80/100 BE1-SSA2025MU212 2550
7.0~10.0 36 100/120 BE1-SSA2025MU214
0.75 1.00 10.0~13.0 36 100/120 BE1-SSA2025MU216 2650
13.0~18.0 50 100/120 BE1-SSA2025MU221
10.0~13.0 50 120/150 BE1-SSA2025MU216H2820
181.10 1.50
13.0~18.0 36+36 120/150 BE1-SSA2025MU221H
1.10 1.50 18.0~25.0 50+50 120/150 BE1-SSA2525MU2223060
10.0~13.0 50 120/150 BE1-SSA2525MU2161.50 2.00
13.0~18.0 36+36 150/200 BE1-SSA2525MU221 3060
1.50 2.00 18.0~25.0 50+50 150/200 BE1-SSA2525MU222M 3060
2.20 3.00 18.0~25.0 50+50 200/250 BE1-SSA2525MU222H 3600
MRP( ` )( ` )( ` )( ` )( ` )
Std. Power Rating forSingle Phase Motor at
220V AC
KW HP
Relay Range(Amp)
Standard Model(with Ammeter)
Reference
Capacitor Rating(MFD)
Run Start
0.37 0.50 4.0~6.0 25 80/100 BE1-SDA2025MU210
0.55 0.75 5.5~8.0 36 80/100 BE1-SDA2025MU212 2760
7.0~10.0 36 100/120 BE1-SDA2025MU214
0.75 1.00 10.0~13.0 36 100/120 BE1-SDA2025MU216 2820
13.0~18.0 50 100/120 BE1-SDA2025MU221
10.0~13.0 50 120/150 BE1-SDA2025MU216H 181.10 1.50
13.0~18.0 36+36 120/150 BE1-SDA2025MU221H2970
1.10 1.50 18.0~25.0 50+50 120/150 BE1-SDA2525MU222
10.0~13.0 50 120/150 BE1-SDA2525MU216 33001.50 2.00
13.0~18.0 36+36 150/200 BE1-SDA2525MU221
1.50 2.00 18.0~25.0 50+50 150/200 BE1-SDA2525MU222M 3300
2.20 3.00 18.0~25.0 50+50 200/250 BE1-SDA2525MU222H 3800
MRP( ` )( ` )( ` )( ` )( ` )
Std.Pkg.
(No ' s )
Relay Range(Amp)
Deluxe Model(with Ammeter)
Reference
Capacitor Rating(MFD)
Run Start
Std.Pkg.
(No ' s )
Single Phase SPCU Deluxe Model With 2Pole Contactor & 2Pole Overload Relay LR7D
Std. Power Rating forSingle Phase Motor at
220V AC
KW HP
ANMOL MOTOR STARTER
MRP w.e.f. 19th April 2011 69
Submersible Pump Control UnitSPCU - DOL Standard Model
B E 1 - S S D X 2 0 4 3 0 8 2 . 5 - 4 . 0 4 6 0 0
B E 1 - S S D X 2 0 4 3 1 0 4 . 0 - 6 . 0 4 6 0 0
B E 1 - S S D X 2 0 4 3 1 2 5 . 5 - 8 . 0 4 6 0 0
B E 1 - S S D X 2 0 4 3 1 4 7 - 1 0 4 6 0 0 1 2
B E 1 - S S D X 2 0 4 3 1 6 1 0 - 1 3 4 6 0 0
B E 1 - S S D X 2 0 4 3 2 1 1 3 - 1 8 4 7 5 0
B E 1 - S S D X 2 5 4 3 2 1 H 1 3 - 1 8 4 9 7 5
B E 1 - S S D X 2 5 4 3 2 2 1 8 - 2 5 4 9 7 5
Std.Pkg.
(No ' s )Re fe rence
Relay RangeAmps
MRP( `̀̀̀̀ )
SPCU - DOL Deluxe Model
B E 1 - S D D X 2 0 4 3 0 8 2 . 5 - 4 . 0 6 4 2 5
B E 1 - S D D X 2 0 4 3 1 0 4 . 0 - 6 . 0 6 4 2 5
B E 1 - S D D X 2 0 4 3 1 2 5 . 5 - 8 . 0 6 4 2 5
B E 1 - S D D X 2 0 4 3 1 4 7 - 1 0 6 4 2 5 8
B E 1 - S D D X 2 0 4 3 1 6 1 0 - 1 3 6 4 2 5
B E 1 - S D D X 2 0 4 3 2 1 1 3 - 1 8 6 7 0 0
B E 1 - S D D X 2 5 4 3 2 1 H 1 3 - 1 8 7 0 5 0
B E 1 - S D D X 2 5 4 3 2 2 1 8 - 2 5 7 0 5 0
Std.Pkg.
(No ' s )Re fe rence
Relay RangeAmps
MRP( `̀̀̀̀ )
SPCU-Automatic Star Delta Standard Model
B E 3 - S S D X 2 0 4 3 0 8 2 . 5 - 4 . 0 8 9 5 0
B E 3 - S S D X 2 0 4 3 1 0 4 . 0 - 6 . 0 8 9 5 0
B E 3 - S S D X 2 0 4 3 1 2 5 . 5 - 8 . 0 8 9 5 0
B E 3 - S S D X 2 0 4 3 1 4 7 - 1 0 8 9 5 0
B E 3 - S S D X 2 0 4 3 1 6 1 0 - 1 3 8 9 5 0 6
B E 3 - S S D X 2 0 4 3 2 1 1 3 - 1 8 9 2 0 0
B E 3 - S S D X 2 5 4 3 2 2 1 8 - 2 5 9 4 7 0
B E 3 - S S D 4 0 3 5 N 3 5 3 # 2 3 - 3 2 1 7 5 0 0
B E 3 - S S D 4 0 3 5 N 3 5 5 # 3 0 - 4 0 1 7 6 0 0
Std. Pkg.(No ' s )
Re fe rence Re lay Range (A ) M R P ( `̀̀̀̀ )
SPCU-Automatic Star Delta Type Deluxe Model
B E 3 - S D D X 2 0 4 3 0 8 2 . 5 - 4 . 0 1 0 6 0 0
B E 3 - S D D X 2 0 4 3 1 0 4 . 0 - 6 . 0 1 0 6 0 0
B E 3 - S D D X 2 0 4 3 1 2 5 . 5 - 8 . 0 1 0 6 0 0
B E 3 - S D D X 2 0 4 3 1 4 7 - 1 0 1 0 6 0 0 6
B E 3 - S D D X 2 0 4 3 1 6 1 0 - 1 3 1 0 6 0 0
B E 3 - S D D X 2 0 4 3 2 1 1 3 - 1 8 1 1 0 0 0
B E 3 - S D D X 2 5 4 3 2 2 1 8 - 2 5 1 1 3 0 0
How to order Starter• Complete the code by replacing the black square () by the letter(s)
corresponding to the Coil Voltage selected.• Starters / SPCU selection should be based on the FLC of Pump/Motor &
Coil Voltage required as per installation.• Anmol Starters should be ordered in standard packing for each model.
# Wide operating band encapsulated magnet coil** Prices are for standard Coil Voltages. Please specify Coil Voltage.
Coil Voltage Codes (Standard) for SPCU/DOL/Auto DOL Starter
Coil Voltage (AC) 50Hz 380# 415#
Coil Code** Q N
Anmol Motor Starter Spares
3 P O v e r l o a d R e a l y t y p e L R 3 D M LR3-DM09305~314 925 13 P O v e r l o a d R e a l y t y p e L R 3 D M L R 3 - D M 1 2 3 1 6 925 13 P O v e r l o a d R e a l y t y p e L R 3 D M LR3-DM16321~322 1040 1T P M C B , 6 3 A 1 0 k A ' C ' c u r v e C S M B 3 C 6 3 N 1570 1P n e u m a t i c S D T i m e r ( 1 - 3 0 S e c ) TA2 -DS2 1200 1S t a r t C o n t a c t - S n a p f i t SC09 -25A 100 1 0S t a r t N O B l o c k L A 9 - D 0 9 9 0 6 105 1 0O N I n d i c a t i n g L a m p ( R e d ) R C B 2 - B V N 6 4 103 1 0T R I P I n d i c a t i n g L a m p ( A m b e r ) R C B 2 - B V N 6 5 103 1 0R Y B P h a s e i n d i c a t i n g L a m p RCB2-BVD74~5~6 103 1 0Te r m i n a l B l o c k , 2 w a y, 1 5 A TB2W15A 5 5 1 0Te r m i n a l B l o c k , 3 w a y, 6 0 A TB3W60A 200 1 0Te r m i n a l B l o c k , 6 w a y, 6 0 A TB6W60A 200 1 0C o n t a c t o r E x t n . B l o c k f o r S D S EXT01 125 1 0R e l a y E x t n . B l o c k f o r S D S EXT02 125 1 0S t o p P u s h b u t t o n ( R e d ) P B T L 100 1 0Connector Assy.for Autoswitch (BE1-DXS) C A S P P 7 5 1 0A u t o S w i t c h AS1045 100 1V o l t a g e S e l e c t o r S w i t c h VSS10 150 1A u t o / M a n u a l S w i t c h ( f o r S P C U ) RSAM16 175 1 0A u t o / M a n u a l S w i t c h ( f o r B E 1 - D X S ) RSAM06 120 1 0S P P / B Y PA S S S w i t c h R S S B 120 1 0V o l t m e t e r O N / O F F S w i t c h RSVM 150 1 0A m m e t e r ( 0 - 2 0 … 1 2 0 A ) AM20A 350 1A m m e t e r ( 0 - 5 0 … 3 0 0 A ) AM50A 350 1A m m e t e r ( 0 - 7 5 / 5 A ) AM755 400 1A m m e t e r ( 0 - 1 0 0 / 5 A ) AM1005 400 1V o l t m e t e r ( 0 - 5 0 0 V ) VM500 375 1S t a r t N O B l o c k LA9 -D09906M 105 1 0A m m e t e r ( 0 - 1 0 … 6 0 A ) AM10A 350 1A m m e t e r ( 0 - 1 5 … 9 0 A ) AM15A 350 1A m m e t e r ( 0 - 2 5 … 1 5 0 A ) AM25A 350 1V o l t m e t e r ( 0 - 3 0 0 V ) VM300 375 1Te r m i n a l B l o c k , 3 w a y, 3 0 A TB3W30A 180 1 0Te r m i n a l B l o c k , 5 w a y, 3 0 A TB5W30A 180 1 0
Refe renceDescr ip t ion MRP( `̀̀̀̀ )
Std.Pakg.(No's.)
Auto DOL Starter in S.S Enclosure
B E 1 - D X S 2 0 4 3 0 7 1 . 6 - 2 . 5 2 0 7 0
B E 1 - D X S 2 0 4 3 0 8 2 . 5 - 4 . 0 2 0 7 0
B E 1 - D X S 2 0 4 3 1 0 4 . 0 - 6 . 0 2 0 7 0
B E 1 - D X S 2 0 4 3 1 2 5 . 5 - 8 . 0 2 0 7 0
B E 1 - D X S 2 0 4 3 1 4 7 - 1 0 2 0 7 0 1 2
B E 1 - D X S 2 0 4 3 1 6 1 0 - 1 3 2 0 7 0
B E 1 - D X S 2 0 4 3 2 1 1 3 - 1 8 2 1 8 0
B E 1 - D X S 2 5 4 3 2 1 H 1 3 - 1 8 2 3 0 0
B E 1 - D X S 2 5 4 3 2 2 1 8 - 2 5 2 3 0 0
Std.Pkg.
(No ' s )Re fe rence
Relay Range(Amps )
M R P ( `̀̀̀̀ )
Automatic Star Delta Starter in S.S Enclosure
4.0 3 .0 BE3-D X M 204 308 2.5 to 4.0
5 .5 4 .0 BE3-D X M 204 310 4.0 to 6.0
7 .5 5 .5 BE3-D X M 204 312 5.5 to 8.0 5 5 7 5 4
12 .0 9 .0 BE3-D X M 204 314 7.0 to 10.0
15 .0 11 .0 BE3-D X M 204 316 10.0 to 13.0
2 0 . 0 1 5 . 0 BE3-D X M 204 32 1 13 .0 to 18 .0 6 4 0 0 4
BE3-D X M 25 4 321H 13.0 to 18.025 .0 18 .0
BE3-D X M 25 4 322 18.0 to 25.07 8 0 0 4
Std.Pkg.
(No ' s )Re fe rence
Relay RangeAmps
MRP( `̀̀̀̀ )
Std. Power Ratingfor 3 Ph. Motor
at 415VHP kW
Std. Pkg.(No ' s )
Re fe rence Re lay Range (A ) M R P ( `̀̀̀̀ )
ANMOL MOTOR STARTER
MRP w.e.f. 19th April 201170
MOTOR STARTER
DOL Starter with D range Contactor in Plastic Enclosure
0 .50 0 .37 LE1-D173 305 0.63 to 1.00
0 .75 0 .55 LE1-D173 306 1.00 to 1.60
1 .50 1 .10 LE1-D173 307 1.60 to 2.50
2 .00 1 .50 LE1-D173 308 2.50 to 4.00 1 4 7 5 1
3 .00 2 .20 LE1-D173 310 4.00 to 6.00
5 .00 3 .70 LE1-D173 312 5.50 to 8.00
5 .50 4 .00 LE1-D173 314 7.00 to 10.0
7 .50 5 .50 LE1-D173 316 10.0 to 13.0
12 .0 9 .0 LE1-D253 321 13.0 to 18.0
15 .0 11 .0 LE1-D253 322 18.0 to 25.03 2 5 0
1
DOL Starter with D range Contactor in S.S. Enclosure
0 .50 0 .37 BE1 -D1735 3 0 5 0.63 to 1.00
0 .75 0 .55 BE1 -D1735 3 0 6 1.00 to 1.60
1 .50 1 .10 BE1 -D1735 3 0 7 1.60 to 2.50
2 .00 1 .50 BE1 -D1735 3 0 8 2.50 to 4.00
3 .00 2 .20 BE1 -D1735 3 1 0 4.00 to 6.00
5 .00 3 .70 BE1 -D1735 3 1 2 5.50 to 8.00
5 .50 4 .00 BE1 -D1735 3 1 4 7.00 to 10.0 1
7 .50 5 .50 BE1 -D1735 3 1 6 10.0 to 13.0
12 .0 9 . 0 BE1 -D2535 3 2 1 13.0 to 18.0 3400
15 .0 11 .0 BE1 -D2535 3 2 2 18.0 to 25.0 3400
20 .0 15 .0 BE1 -D3235 3 5 3 23.0 to 32.0 6550
30 .0 22 .0 BE1 -D4035 3 5 5 28.0 to 40.0 9400
35 .0 25 .0 BE1 -D5035 3 5 7 38.0 to 50.0 9800
40 .0 30 .0 BE1 -D6535 3 5 9 48.0 to 70.0 10700
Motor Starters for Industrial SegmentConforming IS13947-4
How to order :
(i) Complete code by replacing the blue square
() by the letter(s) corresponding to the CoilVoltage selected.
(ii) Starters should to be selected based on theFLC of Pump / Motor & Coil Voltage required.
** DOL Motor Starter are available only in theabove Standard Coil Voltages.
Coil Voltage Codes (Standard) for DOL Starters
M o t o r S t a r t e r Vo l tage* *
240V 415V
BE1 -D / LE1 -D U W N
# Prices are for standard Coil Voltages. Please specify Coil Voltage.
MRP (Rs.)
Std. Power Ratingfor 3 Ph. Motor
at 415V HP KW
ReferenceStd. Pkg.
(No's)
Relay RangeAmps
HP KW
MRP(Rs.)
Std. Power Ratingfor 3 Ph. Motor
at 415V HP KW
ReferenceStd. Pkg.
(No's)
Relay Range(Amps)
HP KW
1475
DOL Starter with 4P Contactor TC1-DX & TR2D Overload Relay
7 . 5 0 5 . 5 0 BE1-D X A 204 316 9 . 0 ~ 13 19001
1 2 . 0 9 . 0 BE1-D X A 204 321 1 2 ~ 18 2070
1 5 . 0 1 1 . 0 BE1-D X A 254 322 1 7 ~ 25 3 2 0 0
Std.Pkg.
(No ' s )Re fe rence
Relay RangeAmps
MRP( ` )( ` )( ` )( ` )( ` )
Std. Power Ratingfor 3 Ph. Motor
at 415VHP kW
Automatic Star Delta Starter with 4P Contactor TC1-DX & TypeTR2 OLR, Electronic Star Delta Timer
7.5 5 .5 BE3-D X A 2 0 4 312 5.0 ~ 8.0 1
12 .0 9 .0 BE3-D X A 2 0 4 314 7 .0~ 1 0 7 6 0 0
15 .0 11 .0 BE3-D X A 2 0 4 316 9 . 0 ~ 13
2 0 . 0 1 5 . 0 BE3-D X A 2 0 4 32 1 1 2 ~ 18 7 8 0 0 1
BE3-D X A 2 5 4 321 12 ~ 1825 .0 18 .0
BE3-D X A 2 5 4 322 18~ 258 6 0 0 1
Std.Pkg.
(No ' s )Re fe rence
Relay RangeAmps
MRP( ` )( ` )( ` )( ` )( ` )
Std. Power Ratingfor 3 Ph. Motor
at 415VHP kW
# Prices are for standard Coil Voltages. Please specify Coil Voltage.
How to order Star Delta Starter :(i) Complete the code by replacing the blue square () by the letter(s)
corresponding to the Coil Voltage selected.
(ii) Star Delta starters should be selected based on the FLC of the Pump/Motorphase current (Motor FLC X 0.58) & Coil Voltage required.
Reversing Starter with D range Contactor in S.S Enclosure
0.50 0.37 B E 2 - D 1 7 3 5 3 0 5 0.63 to 1.00
0.75 0.55 B E 2 - D 1 7 3 5 3 0 6 1.00 to 1.60
1 . 5 0 1 . 1 0 B E 2 - D 1 7 3 5 3 0 7 1 .60 to 2 .50
2 . 0 0 1 . 5 0 B E 2 - D 1 7 3 5 3 0 8 2 .50 to 4 .00 5 8 5 0 1
3 . 0 0 2 . 2 0 B E 2 - D 1 7 3 5 3 1 0 4 .00 to 6 .00
5 . 0 0 3 . 7 0 B E 2 - D 1 7 3 5 3 1 2 5 .50 to 8 .00
5 . 5 0 4 . 0 0 B E 2 - D 1 7 3 5 3 1 4 7 .00 to 10 .0
7 . 5 0 5 . 5 0 B E 2 - D 1 7 3 5 3 1 6 10 .0 to 13 .0
1 2 . 0 0 9 . 0 0 B E 2 - D 2 5 3 5 3 2 1 13 .0 to 18 .0 7 1 5 0
1 5 . 0 1 1 . 0 B E 2 - D 2 5 3 5 3 2 2 18 .0 to 25 .0 7 5 5 0
1
2 0 . 0 1 5 . 0 B E 2 - D 3 2 3 5 3 5 3 23 .0 to 32 .0 1 1 9 0 0 1
MRP(Rs.)
Std. Power Ratingfor 3 Ph. Motor
at 415V HP KW
ReferenceStd. Pkg.
(No's)Relay Range
Amps
* Industrial Starters are available in the above Standard coil voltages with wideband operating range
Coil Voltage Codes (Standard) Industrial Starters TC1-DX
Indus t r ia l Starter Voltage
3 8 0* 4 1 5*
BE1-DXA / BE3 -DXA Q N
MRP w.e.f. 19th April 2011 71
MOTOR STARTER
Automatic Star Delta Starter with D range Contactor, LR1 OLR &Electronic Star Delta Timer
Star Delta Starter in S.S EnclosureSemi Automatic
3 . 0 4 . 0 BE3 -D1735 308SA 2 . 5 t o 4 . 0
4 . 0 5 . 5 BE3-D1735 310SA 4 . 0 t o 6 . 0
5 . 5 7 . 5 BE3-D1735 312SA 5 . 5 t o 8 . 0 4 8 0 0 1
9 . 0 1 2 BE3-D1735 314SA 7 . 0 t o 1 0 . 0
1 1 1 5 BE3-D1735 316SA 1 0 . 0 t o 1 3 . 0
1 5 2 0 BE3-D2535 321SA 1 3 . 0 t o 1 8 . 0
1 8 2 5 BE3-D2535 322SA 1 8 . 0 t o 2 5 . 06 7 0 0 1
# Prices are for standard Coil Voltages.
Please specify Coil Voltage.
3 . 0 4 . 0 B E 3 - D 1 7 3 5 3 0 8 2 .5 to 4 .0
4 . 0 5 . 5 B E 3 - D 1 7 3 5 3 1 0 4 .0 to 6 .0
5 . 5 7 . 5 B E 3 - D 1 7 3 5 3 1 2 5 .5 to 8 .0 6 6 0 0 1
9 . 0 1 2 B E 3 - D 1 7 3 5 3 1 4 7 .0 to 10 .0
1 1 1 5 B E 3 - D 1 7 3 5 3 1 6 10 .0 to 13 .0
1 5 2 0 B E 3 - D 2 2 3 5 3 2 1 13 .0 to 18 .0 6 8 0 0 1
1 8 2 5 B E 3 - D 2 5 3 5 3 2 2 18 .0 to 25 .0 7 8 5 0 1
2 2 3 0 B E 3 - D 3 2 3 5 3 2 2 18 .0 to 25 .0 1 5 2 0 0 1
2 5 3 5 B E 3 - D 3 2 3 5 3 5 3 23 .0 to 32 .0 1 5 2 0 0 1
3 0 4 0 B E 3 - D 4 0 3 5 3 5 5 30 .0 to 40 .0 1 6 5 0 0 1
3 7 5 0 B E 3 - D 5 0 3 5 3 5 5 30 .0 to 40 .0 2 1 5 0 0 1
5 1 7 0 B E 3 - D 6 3 3 5 3 5 9 48 .0 to 57 .0 3 7 0 0 0 1
5 9 8 0 B E 3 - D 8 0 3 5N 3 6 1 57 .0 to 66 .0 4 1 1 0 0 1
7 5 1 0 0 B E 3 -F 1 1 5 3 6 3 66 .0 to 80 .0 5 3 0 0 0 1
9 0 1 2 5 BE3 -F115N 1 0 5 65 .0 to 105 .0 5 3 0 0 0 1
1 1 0 1 1 5 BE3 -F150N 1 2 5 80 .0 to 125 .0 5 7 5 0 0 1
1 3 2 1 8 0 BE3 -F185N 160 100.0 to 160.0
1 6 0 2 2 0 BE3 -F185N 200 125.0 to 200.01 0 0 0 0 0 1
2 0 0 2 7 0 BE3 -F265N 250 160.0 to 250.0 1 0 0 8 0 0 1
2 2 0 3 0 0 BE3 -F330N 315 200.0 to 315.0 1 1 5 0 0 0 1
2 6 0 3 5 0 BE3 -F330N 315 200.0 to 315.0 1 1 5 0 0 0 1
AC Coil Voltage Codes ( Standard ) for Star Delta
Motor Starter Voltage
380# 415
BE3-D / B E3 - F N W N
# Wide Band Coil available for Star Delta Starters upto 40 HP only.
MRP (`)(`)(`)(`)(`)
Std. Power Ratingfor 3 Ph. Motor
at 415V KW HP
ReferenceStd.Pkg.
(No's)
Relay RangeAmps
MRP (`)(`)(`)(`)(`)
Std. Power Ratingfor 3 Ph. Motor
at 415V KW HP
ReferenceStd.Pkg.
(No's)
Relay RangeAmps
Intelligent Auto Transformer Starter withDigital Motor Protection Relay
3 0 4 0 B E 3 - D 6 3 3 5 M A T S 4 0
3 7 5 0 B E 3 - D 8 0 3 5 M A T S 5 0
5 1 7 0 B E 3 - F 1 1 5 M A T S 7 0
5 9 8 0 B E 3 - F 1 1 5 M A T S 8 0
7 5 1 0 0 B E 3 - F 1 5 0 M A T S 1 0 0
9 0 1 2 5 B E 3 - F 1 8 5 M A T S 1 2 5
1 0 0 1 5 0 B E 3 - F 2 2 5 M A T S 1 5 0
1 3 2 1 8 0 B E 3 - F 2 6 5 M A T S 1 8 0
1 6 0 2 2 0 B E 3 - F 3 3 0 M A T S 2 2 0
2 0 0 2 7 0 B E 3 - F 4 0 0 M A T S 2 7 0
2 2 0 3 0 0 B E 3 - F 4 0 0 M A T S 3 0 0
2 5 0 3 3 5 B E 3 - F 5 0 0 M A T S 3 3 5
2 8 0 3 8 0 B E 3 - F 5 0 0 M A T S 3 8 0
3 1 5 4 2 5 B E 3 - F 6 3 0 M A T S 4 2 5
Intelligent Star Delta Starter With Digital Motor Protection Relay
MRP (`)(`)(`)(`)(`)
Std. Power Ratingfor 3ph. Motor
at 415 V KW HP
ReferenceStd.Pkg.
(No's)
P O R
3 0 4 0 B E 3 - D 4 0 3 5 M S D 4 0
3 7 5 0 B E 3 - D 5 0 3 5 M S D 5 0
5 1 7 0 B E 3 - D 6 3 3 5 M S D 7 0
5 9 8 0 B E 3 - D 8 0 3 5 M S D 8 0
7 5 1 0 0 B E 3 - F 1 1 5 M S D 1 0 0
9 0 1 2 5 B E 3 - F 1 1 5 M S D 1 2 5
1 1 0 1 5 0 B E 3 - F 1 5 0 M S D 1 5 0
1 3 2 1 8 0 B E 3 - F 1 8 5 M S D 1 8 0
1 6 0 2 2 0 B E 3 - F 1 8 5 M S D 2 2 0
2 0 0 2 7 0 B E 3 - F 2 6 5 M S D 2 7 0
2 2 0 3 0 0 B E 3 - F 3 3 0 M S D 3 0 0
2 6 0 3 5 0 B E 3 - F 3 3 0 M S D 3 3 5
2 8 0 3 8 0 B E 3 - F 4 0 0 M S D 3 8 0
3 1 5 4 2 5 B E 3 - F 4 0 0 M S D 4 2 5
3 5 5 4 8 0 B E 3 - F 4 0 0 M S D 4 8 0
N o n S t o c k a b l e i t e m
P O R
Motor Starters for Industrial SegmentConforming IS13947-4
1
1
MRP w.e.f. 19th April 201172
Industrial Plugs & SocketsIEC 60309 Series
N o n S t o c k a b l e i t e m
INDUSTRIAL PLUGS & SOCKETS
16I P44
C S 6 2 2 0 5 6 2 4 0 C S 6 2 2 1 0 6 3 1 0
32 C S 6 2 2 1 6 6 3 5 0 C S 6 2 2 2 1 6 4 0 0
16 C S 6 2 2 2 7 6 4 2 0 C S 6 2 2 3 2 6 4 8 0
32 I P67 C S 6 2 2 3 8 6 5 1 0 C S 6 2 2 4 3 6 5 9 0
63 C S 6 3 2 4 9 6 1 7 5 0 C S 6 3 2 5 4 6 1 8 5 0
1 2 5 CS62262 6 6 2 0 0
16I P44
C S 6 2 4 0 4 6 3 8 0 C S 6 2 4 0 9 6 4 1 0
32 C S 6 2 4 1 5 6 5 5 5 C S 6 2 4 2 0 6 5 2 5
16 C S 6 2 4 2 6 6 6 0 0 C S 6 2 4 3 1 6 7 1 0
32 C S 6 2 4 3 7 6 7 2 0 C S 6 2 4 4 2 6 8 6 0
63I P67
C S 6 2 4 4 8 6 2 3 0 0 C S 6 3 4 5 3 6 2 6 0 0
1 2 5 C S 6 3 4 6 3 6 7 5 0 0
16I P44
C S 6 0 0 0 4 6 1 8 0 C S 6 0 0 0 9 6 2 6 0
32 C S 6 0 0 1 5 6 2 6 0 C S 6 0 0 2 0 6 3 8 0
16
I P67
C S 6 0 0 2 6 6 3 7 5 C S 6 0 0 3 1 6 5 0 0
32 C S 6 0 0 3 7 6 5 4 0 C S 6 0 0 4 2 6 5 7 5
63 C S 6 1 0 4 8 6 1 7 5 0 C S 6 1 0 5 3 6 1 8 5 0
1 2 5 C S 6 0 0 6 1 6 5 0 0 0
16I P44
CS66004 (H ) 6 2 5 5 0 CS66109 (H ) 6 3 2 0 0
32 CS66015 (H ) 6 2 9 9 0 CS66020 (H ) 6 3 6 0 0
16I P67
C S 6 6 2 0 0 6 3 3 5 0 C S 6 6 2 0 2 6 4 3 0 0
32 C S 6 6 2 0 1 6 4 6 0 0 C S 6 6 2 0 3 6 5 3 0 0
16I P44
C S 6 2 0 0 4 6 2 5 0
32 C S 6 2 0 1 5 6 3 7 0
16
I P40
C S 6 0 0 4 5 6 6 5 0
32 C S 6 0 0 4 6 6 9 0 0 C S 6 0 0 4 7 6 1 2 0 0
63 C S 6 0 0 4 8 6 4 0 0 0
16I P44
C S A 0 6 M A 0 1 - 4 6 P O R C S A 0 6 M 0 1 - 4 P O R
32 C S A 0 6 M B 0 1 - 4 6 P O R
Std.Pkg.
(No ' s )P roduc t De ta i l
Relay RangeAmps MRP
( ` )( ` )( ` )( ` )( ` )
ProtectionDegree
3PIN, 2P+E 240V AC
Refe renceH
CodeMRP( ` )( ` )( ` )( ` )( ` )
Refe renceH
Code
5 PIN, 3P+N+E 415V AC
P a n e l M o u n t i n g S o c k e t -S p l a s h P r o o f
P a n e l M o u n t i n g S o c k e t -W a t e r T i g h t
S u r f a c e M o u n t i n g S o c k e t -S p l a s h P r o o f
S u r f a c e M o u n t i n g S o c k e t -W a t e r T i g h t
P l u g s - S p l a s h P r o o f
P l u g s - W a t e r T i g h t
S u r f a c e M o u n t i n gI n t e r l o c k e d S w i t c h e dS o c k e t O u t l e t - H o r i z o n t a l
S u r f a c e M o u n t i n gI n t e r l o c k e d S w i t c h e dS o c k e t O u t l e t - V e r t i c a l
C o n n e c t o r - S p l e s h P r o o f
D i s t r i b u t i o n A C / I n d u s t r i a lO u t l e t w i t h P l u g / S o c k e ti n S h e e t S t e e l E n c l o s u r e
F l e x i D i s t r i b u t i o n B o x e s w i t hP r o t e c t i o n f i t t e d w i t h S o c k e t s& w i t h o u t M C B & R C C B
Final Power
Distribution Components
Miniature Circuit Breakers
Distribution Boards
Residual Current Circuit Breakers
MRP w.e.f. 19th April 2011 75
B-SeriesLIGHTING & DISTRIBUTION WITH NO SURGE CURRENT
1Pole
6 CSMB1B6 155 12
10 CSMB1B10 155 12
16 CSMB1B16 155 12
20 CSMB1B20 155 12
25 CSMB1B25 155 12
32 CSMB1B32 155 12
40 CSMB1B40 345 12
50 CSMB1B50 415 12
63 CSMB1B63 415 12
1 P o l e + N
6 C S M B 1 B 6 N 456 6
1 0 CSMB1B10N 456 6
1 6 CSMB1B16N 456 6
2 0 CSMB1B20N 456 6
2 5 CSMB1B25N 456 6
3 2 CSMB1B32N 456 6
4 0 CSMB1B40N 665 6
5 0 CSMB1B50N 735 6
6 3 CSMB1B63N 735 6
2 P o l e
6 C S M B 2 B 6 510 6
1 0 C S M B 2 B 1 0 510 6
1 6 C S M B 2 B 1 6 510 6
2 0 C S M B 2 B 2 0 510 6
2 5 C S M B 2 B 2 5 510 6
3 2 C S M B 2 B 3 2 510 6
4 0 C S M B 2 B 4 0 714 6
5 0 C S M B 2 B 5 0 840 6
6 3 C S M B 2 B 6 3 840 6
3Po le
6 C S M B 3 B 6 761 4
1 0 C S M B 3 B 1 0 761 4
1 6 C S M B 3 B 1 6 761 4
2 0 C S M B 3 B 2 0 761 4
2 5 C S M B 3 B 2 5 761 4
3 2 C S M B 3 B 3 2 761 4
4 0 C S M B 3 B 4 0 1103 4
5 0 C S M B 3 B 5 0 1213 4
6 3 C S M B 3 B 6 3 1213 4
3 P o l e + N
6 C S M B 3 B 6 N 1030 3
1 0 CSMB3B10N 1030 3
1 6 CSMB3B16N 1030 3
2 0 CSMB3B20N 1030 3
2 5 CSMB3B25N 1030 3
3 2 CSMB3B32N 1030 3
4 0 CSMB3B40N 1391 3
5 0 CSMB3B50N 1550 3
6 3 CSMB3B63N 1550 3
4Po le
6 CSMB4B6 1155 3
1 0 C S M B 4 B 1 0 1155 3
1 6 C S M B 4 B 1 6 1155 3
2 0 C S M B 4 B 2 0 1155 3
2 5 C S M B 4 B 2 5 1155 3
3 2 C S M B 4 B 3 2 1155 3
4 0 C S M B 4 B 4 0 1520 3
5 0 C S M B 4 B 5 0 1630 3
6 3 C S M B 4 B 6 3 1630 3
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )C o d eC o d eC o d eC o d eC o d eC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n g
( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )C o d eC o d eC o d eC o d eC o d eC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n g
( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
Miniature Circuit Breaker
T w o s t a g e e a s y s n a p p i n g d e v i c e f o r D i n R a i l M o u n t i n g
B i - c o n n e c t t e r m i n a l s f o r C a b l e a n d B u s b a r
MCB
IS/IEC60898-1-2002
C M / L - 8 8 8 5 7 1 6
MRP w.e.f. 19th April 201176
Miniature Circuit BreakerC-SeriesINDUCTIVE LOAD WITH SURGE CURRENT - MOTOR CIRCUIT APPLICATIONS
1Pole
0 . 5 C S M B 1 C 0 . 5 255 1 2
1 CSMB1C1 255 1 2
2 CSMB1C2 255 1 2
3 CSMB1C3 255 1 2
4 CSMB1C4 255 1 2
5 CSMB1C5 255 1 2
6 CSMB1C6 168 1 2
1 0 C S M B 1 C 1 0 168 1 2
1 6 C S M B 1 C 1 6 168 1 2
2 0 C S M B 1 C 2 0 168 1 2
2 5 C S M B 1 C 2 5 168 1 2
3 2 C S M B 1 C 3 2 168 1 2
4 0 C S M B 1 C 4 0 352 1 2
5 0 C S M B 1 C 5 0 418 1 2
6 3 C S M B 1 C 6 3 418 1 2
8 0 CSMB1C80 1497 3
100 CSMB1C100 1677 3
125 CSMB1C125 1811 3
1 P o l e + N0 . 5 C S M B 1 C 0 . 5 N 556 6
1 C S M B 1 C 1 N 556 62 C S M B 1 C 2 N 556 63 C S M B 1 C 3 N 556 64 C S M B 1 C 4 N 556 65 C S M B 1 C 5 N 556 66 C S M B 1 C 6 N 510 6
1 0 CSMB1C10N 510 61 6 CSMB1C16N 510 62 0 CSMB1C20N 510 62 5 CSMB1C25N 510 63 2 CSMB1C32N 510 64 0 CSMB1C40N 693 65 0 CSMB1C50N 800 66 3 CSMB1C63N 800 6
2Po le0 . 5 C S M B 2 C 0 . 5 666 6
1 CSMB2C1 666 62 CSMB2C2 666 63 CSMB2C3 666 64 CSMB2C4 666 65 CSMB2C5 666 66 CSMB2C6 533 6
1 0 C S M B 2 C 1 0 533 61 6 C S M B 2 C 1 6 533 62 0 C S M B 2 C 2 0 533 62 5 C S M B 2 C 2 5 533 63 2 C S M B 2 C 3 2 533 64 0 C S M B 2 C 4 0 759 65 0 C S M B 2 C 5 0 870 66 3 C S M B 2 C 6 3 870 68 0 CSMB2C80 3321 3
100 CSMB2C100 3545 3125 CSMB2C125 3897 3
3Po le
0 . 5 C S M B 3 C 0 . 5 902 41 CSMB3C1 902 42 CSMB3C2 902 43 CSMB3C3 902 44 CSMB3C4 902 45 CSMB3C5 902 46 CSMB3C6 805 4
1 0 C S M B 3 C 1 0 805 41 6 C S M B 3 C 1 6 805 42 0 C S M B 3 C 2 0 805 42 5 C S M B 3 C 2 5 805 43 2 C S M B 3 C 3 2 805 44 0 CSMB 3 C4 0 1 1 5 0 45 0 CSMB 3 C5 0 1 2 7 6 46 3 CSMB 3 C6 3 1 2 7 6 48 0 CSMB 3 C8 0 5 2 4 1 1
100 CSMB3C100 5583 1125 CSMB3C125 6199 1
3 P o l e + N0 . 5 C S M B 3 C 0 . 5 N 1215 3
1 CSMB 3 C1 N 1 2 1 5 32 CSMB 3 C2 N 1 2 1 5 33 CSMB 3 C3 N 1 2 1 5 34 CSMB 3 C4 N 1 2 1 5 35 CSMB 3 C5 N 1 2 1 5 36 CSMB 3 C6 N 1 0 5 1 3
1 0 CSMB3C10N 1051 31 6 CSMB3C16N 1051 32 0 CSMB3C20N 1051 32 5 CSMB3C25N 1051 33 2 CSMB3C32N 1051 34 0 CSMB3C40N 1440 35 0 CSMB3C50N 1609 36 3 CSMB3C63N 1609 38 0 CSMB3C80N 6180 1
100 CSMB3C100N 6901 1125 CSMB3C125N 6901 1
4Po le0 . 5 C S M B 4 C 0 . 5 1 3 3 8 3
1 CSMB4C1 1338 32 CSMB4C2 1338 33 CSMB4C3 1338 34 CSMB4C4 1338 35 CSMB4C5 1338 36 CSMB4C6 1179 3
1 0 CSMB 4 C1 0 1 1 7 9 31 6 CSMB 4 C1 6 1 1 7 9 32 0 CSMB 4 C2 0 1 1 7 9 32 5 CSMB 4 C2 5 1 1 7 9 33 2 CSMB 4 C3 2 1 1 7 9 34 0 CSMB 4 C4 0 1 5 5 0 35 0 CSMB 4 C5 0 1 6 9 6 36 3 CSMB 4 C6 3 1 6 9 6 38 0 CSMB 4 C8 0 6 6 6 9 1
100 CSMB4C100 6953 1125 CSMB4C125 7854 1
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )C o d eC o d eC o d eC o d eC o d eC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n g
( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )C o d eC o d eC o d eC o d eC o d eC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n g
( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
MCB
• A l l M C B s f r o m 0 . 5 A t o 6 3 A c o n f o r m s t o I S 6 0 8 9 8 - 1 - 2 0 0 2 & a r e I S I m a r k e d• M C B f r o m 8 0 A t o 1 2 5 A c o n f o r m s t o I E C : 6 0 9 4 7 - 2
IS/IEC60898-1-2002
C M / L - 8 8 8 5 7 1 6
MRP w.e.f. 19th April 2011 77
Miniature Circuit BreakerD-SeriesHIGH INDUCTIVE LOAD & HIGH INRUSH CURRENT
1 Po l e
0 . 5 C S M B 1 D 0 . 5 274 1 2
1 CSMB1D1 274 1 2
2 CSMB1D2 274 1 2
3 CSMB1D3 274 1 2
4 CSMB1D4 274 1 2
5 CSMB1D5 274 1 2
6 CSMB1D6 235 1 2
1 0 C S M B 1 D 1 0 235 1 2
1 6 C S M B 1 D 1 6 235 1 2
2 0 C S M B 1 D 2 0 235 1 2
2 5 C S M B 1 D 2 5 235 1 2
3 2 C S M B 1 D 3 2 235 1 2
4 0 C S M B 1 D 4 0 402 1 2
5 0 C S M B 1 D 5 0 440 1 2
6 3 C S M B 1 D 6 3 440 1 2
1 P o l e + N
0 . 5 C S M B 1 D 0 . 5 N 809 6
1 C S M B 1 D 1 N 809 6
2 C S M B 1 D 2 N 809 6
3 C S M B 1 D 3 N 809 6
4 C S M B 1 D 4 N 809 6
5 C S M B 1 D 5 N 809 6
6 C S M B 1 D 6 N 705 6
1 0 CSMB1D10N 705 6
1 6 CSMB1D16N 705 6
2 0 CSMB1D20N 705 6
2 5 CSMB1D25N 705 6
3 2 CSMB1D32N 705 6
4 0 CSMB1D40N 815 6
5 0 CSMB1D50N 993 6
6 3 CSMB1D63N 993 6
2Po le
0 . 5 C S M B 2 D 0 . 5 752 6
1 CSMB2D1 752 6
2 CSMB2D2 752 6
3 CSMB2D3 752 6
4 CSMB2D4 752 6
5 CSMB2D5 752 6
6 CSMB2D6 596 6
1 0 C S M B 2 D 1 0 596 6
1 6 C S M B 2 D 1 6 596 6
2 0 C S M B 2 D 2 0 596 6
2 5 C S M B 2 D 2 5 596 6
3 2 C S M B 2 D 3 2 596 6
4 0 C S M B 2 D 4 0 888 6
5 0 C S M B 2 D 5 0 951 6
6 3 C S M B 2 D 6 3 951 6
3Pole
0 . 5 C S M B 3 D 0 . 5 1 1 8 1 4
1 CSMB3D1 1181 4
2 CSMB3D2 1181 4
3 CSMB3D3 1181 4
4 CSMB3D4 1181 4
5 CSMB3D5 1181 4
6 CSMB3D6 914 4
1 0 C S M B 3 D 1 0 914 4
1 6 C S M B 3 D 1 6 914 4
2 0 C S M B 3 D 2 0 914 4
2 5 C S M B 3 D 2 5 914 4
3 2 C S M B 3 D 3 2 914 4
4 0 CSMB 3 D4 0 1 4 1 1 4
5 0 CSMB 3 D5 0 1 4 2 1 4
6 3 CSMB 3 D6 3 1 4 2 1 4
3 P o l e + N
0 . 5 C S M B 3 D 0 . 5 N 1594 3
1 CSMB 3 D1 N 1 5 9 4 3
2 CSMB 3 D2 N 1 5 9 4 3
3 CSMB 3 D3 N 1 5 9 4 3
4 CSMB 3 D4 N 1 5 9 4 3
5 CSMB 3 D5 N 1 5 9 4 3
6 CSMB 3 D6 N 1 4 6 3 3
1 0 CSMB3D10N 1463 3
1 6 CSMB3D16N 1463 3
2 0 CSMB3D20N 1463 3
2 5 CSMB3D25N 1463 3
3 2 CSMB3D32N 1463 3
4 0 CSMB3D40N 1620 3
5 0 CSMB3D50N 1724 3
6 3 CSMB3D63N 1724 3
4Po le
0 . 5 C S M B 4 D 0 . 5 1 4 3 7 3
1 CSMB4D1 1437 3
2 CSMB4D2 1437 3
3 CSMB4D3 1437 3
4 CSMB4D4 1437 3
5 CSMB4D5 1437 3
6 CSMB4D6 1150 3
1 0 CSMB 4 D1 0 1 1 5 0 3
1 6 CSMB 4 D1 6 1 1 5 0 3
2 0 CSMB 4 D2 0 1 1 5 0 3
2 5 CSMB 4 D2 5 1 1 5 0 3
3 2 CSMB 4 D3 2 1 1 5 0 3
4 0 CSMB 4 D4 0 1 6 1 5 3
5 0 CSMB 4 D5 0 1 7 7 7 3
6 3 CSMB 4 D6 3 1 7 7 7 3
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )C o d eC o d eC o d eC o d eC o d eC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n g
( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )C o d eC o d eC o d eC o d eC o d eC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n g
( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
MCB
N o n S t o c k a b l e i t e m
IS/IEC60898-1-2002
MRP w.e.f. 19th April 201178
Miniature Circuit BreakerDC-Series
1Po le
0 . 5 C S M B 1 D C 0 . 5 305 1 2
1 C S M B 1 D C 1 305 1 2
2 C S M B 1 D C 2 305 1 2
3 C S M B 1 D C 3 305 1 2
4 C S M B 1 D C 4 305 1 2
5 C S M B 1 D C 5 305 1 2
6 C S M B 1 D C 6 280 1 2
1 0 CSMB1DC10 280 1 2
1 6 CSMB1DC16 280 1 2
2 0 CSMB1DC20 280 1 2
2 5 CSMB1DC25 280 1 2
3 2 CSMB1DC32 280 1 2
4 0 CSMB1DC40 385 1 2
5 0 CSMB1DC50 465 1 2
6 3 CSMB1DC63 465 1 2
2Po le
0 . 5 C S M B 2 D C 0 . 5 700 6
1 C S M B 2 D C 1 700 6
2 C S M B 2 D C 2 700 6
3 C S M B 2 D C 3 700 6
4 C S M B 2 D C 4 700 6
5 C S M B 2 D C 5 700 6
6 C S M B 2 D C 6 540 6
1 0 CSMB2DC10 540 6
1 6 CSMB2DC16 540 6
2 0 CSMB2DC20 540 6
2 5 CSMB2DC25 540 6
3 2 CSMB2DC32 540 6
4 0 CSMB2DC40 790 6
5 0 CSMB2DC50 865 6
6 3 CSMB2DC63 865 6
1Po le
2 5 CSMB1 I SO25 193 1 2
4 0 CSMB1 I SO40 225 1 2
6 3 CSMB1 I SO63 251 1 2
8 0 CSMB1 I SO80 314 1 2
100 CSMB1 I SO100 366 1 2
125 CSMB1 I SO125 434 1 2
2Po le
2 5 CSMB2 I SO25 318 6
4 0 CSMB2 I SO40 332 6
6 3 CSMB2 I SO63 426 6
8 0 CSMB2 I SO80 556 6
100 CSMB2 I SO100 556 6
125 CSMB2 I SO125 608 6
Isolators
3Po le
2 5 CSMB3 I SO25 580 4
4 0 CSMB3 I SO40 632 4
6 3 CSMB3 I SO63 699 4
8 0 CSMB3 I SO80 853 4
100 CSMB3 I SO100 853 4
125 CSMB3 I SO125 886 4
4Po le
2 5 CSMB4 I SO25 627 3
4 0 CSMB4 I SO40 754 3
6 3 CSMB4 I SO63 790 3
8 0 CSMB4 I SO80 1017 3
100 CSMB4 I SO100 1017 3
125 CSMB4 I SO125 1071 3
Isolators
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )C o d eC o d eC o d eC o d eC o d eC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n g
( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )C o d eC o d eC o d eC o d eC o d eC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n g
( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )C o d eC o d eC o d eC o d eC o d eC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n g
( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
C o d eC o d eC o d eC o d eC o d eC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n gC u r r e n t r a t i n g( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )
M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
IS/IS/IS/IS/IS/I EC6I EC6I EC6I EC6I EC6 0947-30947-30947-30947-30947-3
1NO+1NC AX 450
1 2 VDC S 1 450
2 4 VDC S 2 450
4 8 VDC S 3 450
2 2 0 V A C S 4 450
Accessories (Factory fitted with MCB)
Current ratingCurrent ratingCurrent ratingCurrent ratingCurrent rating( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )
Un i t MRPUn i t MRPUn i t MRPUn i t MRPUn i t MRP( ` )( ` )( ` )( ` )( ` )
A u x i l l i a r yA u x i l l i a r yA u x i l l i a r yA u x i l l i a r yA u x i l l i a r yC o n t a c tC o n t a c tC o n t a c tC o n t a c tC o n t a c t
Un i t MRPUn i t MRPUn i t MRPUn i t MRPUn i t MRP( ` )( ` )( ` )( ` )( ` )ShunShunShunShunShunttttt T T T T Tr ipripripriprip
MCB
N o n S t o c k a b l e i t e m
N o n S t o c k a b l e i t e m
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )
IS/IEC60898-2-2002
MRP w.e.f. 19th April 2011 79
Residual Current Circuit Breaker
2Po le
1 6 CSRB2P16A30 3 0 2017 6
1 6 C S R B 2 P 1 6 A 1 0 0 100 1 9 5 4 61 6 C S R B 2 P 1 6 A 3 0 0 300 1 9 5 4 62 5 CSRB2P25A30 3 0 2022 62 5 C S R B 2 P 2 5 A 1 0 0 100 1 9 6 5 62 5 C S R B 2 P 2 5 A 3 0 0 300 1 9 6 5 63 2 CSRB2P32A30 3 0 2132 63 2 C S R B 2 P 3 2 A 1 0 0 100 2 1 4 2 63 2 C S R B 2 P 3 2 A 3 0 0 300 2 1 4 2 64 0 CSRB2P40A30 3 0 2126 64 0 C S R B 2 P 4 0 A 1 0 0 100 2 1 2 1 64 0 C S R B 2 P 4 0 A 3 0 0 300 2 1 2 1 66 3 CSRB2P63A30 3 0 2855 66 3 C S R B 2 P 6 3 A 1 0 0 100 2 9 2 6 66 3 C S R B 2 P 6 3 A 3 0 0 300 2 9 2 6 68 0 CSRB2P80A30 3 0 4274 68 0 C S R B 2 P 8 0 A 1 0 0 100 4 2 7 4 68 0 C S R B 2 P 8 0 A 3 0 0 300 4 2 7 4 6
100 C S R B 2 P 1 0 0 A 3 0 3 0 4 2 7 4 6100 CSRB2P100A100 100 4274 6100 CSRB2P100A300 300 4274 6
4Po le1 6 CSRB4P16A30 3 0 2534 31 6 C S R B 4 P 1 6 A 1 0 0 100 2 5 0 8 31 6 C S R B 4 P 1 6 A 3 0 0 300 2 5 0 8 32 5 CSRB4P25A30 3 0 2560 32 5 C S R B 4 P 2 5 A 1 0 0 100 2 4 6 1 32 5 C S R B 4 P 2 5 A 3 0 0 300 2 4 6 1 33 2 CSRB4P32A30 3 0 2686 33 2 C S R B 4 P 3 2 A 1 0 0 100 2 6 4 9 33 2 C S R B 4 P 3 2 A 3 0 0 300 2 6 4 9 34 0 CSRB4P40A30 3 0 2613 34 0 C S R B 4 P 4 0 A 1 0 0 100 2 6 6 0 34 0 C S R B 4 P 4 0 A 3 0 0 300 2 6 6 0 36 3 CSRB4P63A30 3 0 3145 36 3 C S R B 4 P 6 3 A 1 0 0 100 2 9 2 6 36 3 C S R B 4 P 6 3 A 3 0 0 300 2 9 2 6 38 0 CSRB4P80A30 3 0 4713 38 0 C S R B 4 P 8 0 A 1 0 0 100 4 7 0 3 38 0 C S R B 4 P 8 0 A 3 0 0 300 4 7 0 3 3
100 C S R B 4 P 1 0 0 A 3 0 3 0 4 8 3 3 3100 CSRB4P100A100 100 4912 3100 CSRB4P100A300 300 4912 3
S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .S t g . P k g .( N o ' s )( N o ' s )( N o ' s )( N o ' s )( N o ' s )C o d eC o d eC o d eC o d eC o d e
C u r r e n tC u r r e n tC u r r e n tC u r r e n tC u r r e n tr a t i n gr a t i n gr a t i n gr a t i n gr a t i n g
( A m p s . )( A m p s . )( A m p s . )( A m p s . )( A m p s . )
M R PM R PM R PM R PM R P( ` )( ` )( ` )( ` )( ` )
S e n s i t i v i t yS e n s i t i v i t yS e n s i t i v i t yS e n s i t i v i t yS e n s i t i v i t y
RCCB
IS12640-1-2008
CM/L-3148552
N o t e : R a t i n g f r o m 1 6 A t o 6 3 A c o n f o r m s t o I S 1 2 6 4 0 - 1 - 2 0 0 8 a n d a s I S I m a r k e d
MRP w.e.f. 19th April 201180
Distribution Board
TPN DB - Horizontal
TTTTT y p ey p ey p ey p ey p e P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e N o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e s M R PM R PM R PM R PM R P
( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g ) ( R s . )( R s . )( R s . )( R s . )( R s . )
4 way S i ng le Doo r CSDBTPNHSD04 8+12 1930
6 way S i ng le Doo r CSDBTPNHSD06 8+18 2415
8way S i ng le Doo r CSDBTPNHSD08 8+24 2870
12 way S i ng le Doo r CSDBTPNHSD12 8+36 4200
16 way S i ng le Doo r CSDBTPNHSD16 8+48 5135
4 way Doub le Doo r CSDBTPNHDD04 8+12 2560
6 way Doub le Doo r CSDBTPNHDD06 8+18 3165
8way Doub le Doo r CSDBTPNHDD08 8+24 3790
12 way Doub le Doo r CSDBTPNHDD12 8+36 5650
16 way Doub le Doo r CSDBTPNHDD16 8+48 6910
T y p eT y p eT y p eT y p eT y p e P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e s
( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )
4 way S i ng le Doo r CSDBSPNSD04 4 695
8 way S i ng le Doo r CSDBSPNSD08 8 875
12 way S i ng le Doo r CSDBSPNSD12 12 1045
16 way S i ng le Doo r CSDBSPNSD16 16 1305
4 way Doub le Doo r CSDBSPNDD04 4 1000
8 way Doub le Doo r CSDBSPNDD08 8 1255
12 way Doub le Doo r CSDBSPNDD12 12 1515
16 way Doub le Doo r CSDBSPNDD16 16 1900
M R PM R PM R PM R PM R P ( ` )( ` )( ` )( ` )( ` )
SPN DB
T y p eT y p eT y p eT y p eT y p e P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e s
( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )M R PM R PM R PM R PM R P ( ` )( ` )( ` )( ` )( ` )
DB
N o t e :N o t e :N o t e :N o t e :N o t e : DB ' s w i t h Lock & Key op t iona l on reques t .
TTTTT y p ey p ey p ey p ey p e P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e M R P M R P M R P M R P M R P ( ` )( ` )( ` )( ` )( ` )
SPN 4 Way S INGLE DOOR D I S TR I BU T ION BOARD / S TD . CSDBSPNSD04S 485
SPN 8 Way S INGLE DOOR D I S TR I BU T ION BOARD / S TD CSDBSPNSD08S 600
SPN 12 Way S INGLE DOOR D I S TR I BU T ION BOARD / S TD CSDBSPNSD12S 830
SPN 16 Way S INGLE DOOR D I S TR I BU T ION BOARD / S TD CSDBSPNSD16S 1030
SPN 4 Way DOUBLE DOOR D I S TR I BU T ION BOARD (W I THOUT KEY ) CSDBSPNDD04S 830
SPN 8 Way DOUBLE DOOR D I S TR I BU T ION BOARD (W I THOUT KEY ) / S TD CSDBSPNDD08S 1085
SPN 12 Way DOUBLE DOOR D I S TR I BU T ION BOARD (W I THOUT KEY ) / S TD CSDBSPNDD12S 1415
SPN 16 Way DOUBLE DOOR D I S TR I BU T ION BOARD (W I THOUT KEY ) / S TD CSDBSPNDD16S 1825
SPN WiNclass DB
TTTTT y p ey p ey p ey p ey p e P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e M R P M R P M R P M R P M R P ( ` )( ` )( ` )( ` )( ` )
T PNHSD D I S TR I BU T ION BOARD 04 WAY W INCLASS CSDBTPNHSD04S 1600
TPNHSD D I S TR I BU T ION BOARD 06 WAY W INCLASS CSDBTPNHSD06S 1915
TPNHSD D I S TR I BU T ION BOARD 08 WAY W INCLASS CSDBTPNHSD08S 2145
TPNHSD D I S TR I BU T ION BOARD 12 WAY W INCLASS CSDBTPNHSD12S 2835
TPNHSD D I S TR I BU T ION BOARD 16 WAY W INCLASS CSDBTPNHSD16S 3550
TPNHDD D I S TR I BU T ION BOARD 04 WAY W INCLASS CSDBTPNHDD04S 2300
TPNHDD D I S TR I BU T ION BOARD 06 WAY W INCLASS CSDBTPNHDD06S 2890
TPNHDD D I S TR I BU T ION BOARD 08 WAY W INCLASS CSDBTPNHDD08S 3660
TPNHDD D I S TR I BU T ION BOARD 12 WAY W INCLASS CSDBTPNHDD12S 5220
TPNHDD D I S TR I BU T ION BOARD 16 WAY W INCLASS CSDBTPNHDD16S 6950
TPN WiNclass DB
MRP w.e.f. 19th April 2011 81
TTTTT y p ey p ey p ey p ey p e P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e sN o . o f M o d u l e s M R PM R PM R PM R PM R P
( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g )( I n c o m e r + O u t g o i n g ) ( ` )( ` )( ` )( ` )( ` )
4 way Doub le Doo r C S D B T P N V D D 0 4 - L 8+12 6220
8 way Doub le Doo r C S D B T P N V D D 0 8 - L 8+24 7875
12 way Doub le Doo r C S D B T P N V D D 1 2 - L 8+36 10550
VTPN DB (with provision for MCB as incomer)
TTTTT y p ey p ey p ey p ey p e P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e M R P M R P M R P M R P M R P ( ` )( ` )( ` )( ` )( ` )
D i s t r i bu t i on Boa rd MCCB AS I /C 100A DD04 WAY I P43 CSDBMCCB100DD04 I P43 7260
D i s t r i bu t i on Boa rd MCCB AS I /C 100A DD08 WAY I P43 CSDBMCCB100DD08 I P43 9225
D i s t r i bu t i on Boa rd MCCB AS I /C 100A DD12 WAY I P43 CSDBMCCB100DD12 I P43 12315
D i s t r i bu t i on Boa rd MCCB AS I /C 225A DD04 WAY I P43 CSDBMCCB225DD04 I P43 13535
D i s t r i bu t i on Boa rd MCCB AS I /C 225A DD08 WAY I P43 CSDBMCCB225DD08 I P43 15930
D i s t r i bu t i on Boa rd MCCB AS I /C 225A DD12 WAY I P43 CSDBMCCB225DD12 I P43 16635
VTPN DB (with provision for MCCB as incomer)P r i ces w i t hou t MCCB
D e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o n P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e M C C B R a t i n gM C C B R a t i n gM C C B R a t i n gM C C B R a t i n gM C C B R a t i n g
CSDBMCCB100DD04IP43 100
CSDBMCCB100DD08IP43 100
CSDBMCCB100DD12IP43 100
CSDBMCCB225DD04IP43 150,175,200,225
CSDBMCCB225DD08IP43 150,175,200,225
CSDBMCCB225DD12IP43 150,175,200,225
CSDBMCCB225DD04IP43 150,175,200,225
CSDBMCCB225DD08IP43 150,175,200,225
CSDBMCCB225DD12IP43 150,175,200,225
CSDBMCCB225DD04IP43 150,175,200,225
CSDBMCCB225DD08IP43 150,175,200,225
CSDBMCCB225DD12IP43 150,175,200,225
MCCB Selection Guide
10kA
3Pole / 4Pole
Reference for MCCB WiNbreak CS2A3*/CS2A4*
25kA
3Pole / 4Pole
Reference for MCCB WiNbreak CS3B3*/CS3B4*
35kA
3Pole / 4Pole
Reference for MCCB WiNbreak CS3C3*/CS3C4*
Note: Add MCCB rating in place of *
DB
Type P roduc t Code M R P ( ` )( ` )( ` )( ` )( ` )
4 Way DD C S D B T P N P P I D D 0 4 3950
6 Way DD C S D B T P N P P I D D 0 6 4940
Distribution BoardPPI Distribution Board
Type P roduc t Code M R P ( ` )( ` )( ` )( ` )( ` )
8 Way DD C S D B T P N P P I D D 0 8 5990
12 Way DD C S D B T P N P P I D D 1 2 6930
18kA
3Pole / 4Pole
Reference for MCCB WiNbreak CS3A3*/CS3A4*
D e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o n P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e M R P M R P M R P M R P M R P ( ` )( ` )( ` )( ` )( ` )
4 WAY DD with 63A R/S CSDBPHSDD04RS63 8000
6 WAY DD with 63A R/S CSDBPHSDD06RS63 8185
8 WAY DD with 63A R/S CSDBPHSDD08RS63 9030
12 WAY DD with 63A R/S CSDBPHSDD12RS63 10005
4 WAY DD with 40A R/S CSDBPHSDD04RS40 8010
6 WAY DD with 40A R/S CSDBPHSDD06RS40 8040
8 WAY DD with 40A R/S CSDBPHSDD08RS40 8790
12WAY DD with 40A R/S CSDBPHSDD12RS40 9840
4 WAY DD without R/S CSDBDDPHDD04 6740
6 WAY DD without R/S CSDBDDPHDD06 6840
8 WAY DD without R/S CSDBDDPHDD08 7640
12 WAY DD without R/S CSDBDDPHDD12 8640
Phase Selector DB-TPN Phase Selector DD DB for incorporating MCB/Isolator/RCCB, equipped with 3 Nos 63A Phaseselector switches & 3 No Piano switches
MRP w.e.f. 19th April 201182
7 Segment TPN DD DB With Provision for FP MCB /Isolator/RCCB as incomer, DP MCB/Lsolator/RCCB as sub
incomer and SP MCBs as outgoing
D e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o n P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e M R P M R P M R P M R P M R P ( ` )( ` )( ` )( ` )( ` )
SPN DISTRIBUTION BOARD SINGLE DOOR 4 Way Product Code #
SPN DISTRIBUTION BOARD SINGLE DOOR 6 Way Product Code #
SPN DISTRIBUTION BOARD SINGLE DOOR 8 Way Product Code #
SPN DISTRIBUTION BOARD SINGLE DOOR 10 Way Product Code #
SPN DISTRIBUTION BOARD SINGLE DOOR 12 Way Product Code #
SPN DISTRIBUTION BOARD SINGLE DOOR 16 Way Product Code #
TPN DISTRIBUTION BOARD SINGLE DOOR 04 WAY Product Code #
TPN DISTRIBUTION BOARD SINGLE DOOR 06 WAY Product Code #
TPN DISTRIBUTION BOARD SINGLE DOOR 08 WAY Product Code #
TPN DISTRIBUTION BOARD SINGLE DOOR 12 WAY Product Code #
TPN DISTRIBUTION BOARD DOUBLE DOOR 04 WAY Product Code #
TPN DISTRIBUTION BOARD DOUBLE DOOR 06 WAY Product Code #
TPN DISTRIBUTION BOARD DOUBLE DOOR 08 WAY Product Code #
TPN DISTRIBUTION BOARD DOUBLE DOOR 12 WAY Product Code #
Prewired Distribution Board fitted with Busbar,Terminal Block for incoming/out going phase neutral & Earth duly wired withProvision ISO/RCCB/MCB as incomer and SP out going ( without MCBs)
D e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o n P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e M R P M R P M R P M R P M R P ( ` )( ` )( ` )( ` )( ` )
FLEXI DD DB 2 ROW 13MODULES CSDBFLDD2R13 3120
FLEXI DD DB 3 ROW 13MODULES CSDBFLDD3R13 3675
FLEXI DD DB 4 ROW 13MODULES CSDBFLDD4R13 4065
WINTRIP FLEXI (Tier) DBs (with metal door)
D e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o n P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e M R P M R P M R P M R P M R P ( ` )( ` )( ` )( ` )( ` )
SPN DISTRIBUTION BOARD DOUBLE DOOR 4 Way Product Code #
SPN DISTRIBUTION BOARD DOUBLE DOOR 6 Way Product Code #
SPN DISTRIBUTION BOARD DOUBLE DOOR 8 Way Product Code #
SPN DISTRIBUTION BOARD DOUBLE DOOR 10 Way Product Code #
SPN DISTRIBUTION BOARD DOUBLE DOOR 12 Way Product Code #
TPN DISTRIBUTION BOARD DOUBLE DOOR 04 WAY Product Code #
TPN DISTRIBUTION BOARD DOUBLE DOOR 06 WAY Product Code #
TPN DISTRIBUTION BOARD DOUBLE DOOR 08 WAY Product Code #
TPN DISTRIBUTION BOARD DOUBLE DOOR 12 WAY Product Code #
TPN DISTRIBUTION BOARD DOUBLE DOOR 16 WAY Product Code #
Double Door DB with Acrylic window
7 Segment Distribution Board
D e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o n P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e M R P M R P M R P M R P M R P ( ` )( ` )( ` )( ` )( ` )
CSDB7SEGDD04 6240
CSDB7SEGDD06 7035
CSDB7SEGDD08 7855
CSDB7SEGDD12 9985
DB
# Prices on request
MRP w.e.f. 19th April 2011 83
METAL ENCLOSURES (with Din Rail)For Mounting WiNtrip MCBs / RCCBs / Isolators
SP Enc lo su re C S D B M C B E S P 247 24
DP Enc lo su re C S D B M C B E D P 247 24
TP Enc lo su re C S D B M C B E T P 282 12
FP Enc lo su re C S D B M C B E F P 282 12
Plug and Socket DBs (without MCB)Powder Coated Sheet Metal Deep Drawn DBs with Plug & Socket including insulated Neutral link,adjustable Din Rail and connecting links.
Type P roduc t CodeMRP S t gS t gS t gS t gS t g ..... P k g .P k g .P k g .P k g .P k g .
( ` )( ` )( ` )( ` )( ` ) (No . s )
10Amp SPN C SDBPSSPN010 700 12
20Amp SPN C SDBPSSPN020 700 12
20Amp TPN C SDBPS T PN020 2000 6
30Amp TPN C SDBPS T PN030 2000 6
PLUG and SOCKETS (Metal Clad)
10Amp SPN P l ug CSDBPSPN010 132 36
10Amp SPN Socke t CSDBSSPN010 132 36
20Amp SPN P l ug CSDBPSPN020 150 36
20Amp SPN Socke t CSDBSSPN020 159 36
20Amp TPN P l ug CSDBP TPN020 186 36
20Amp TPN Socke t CSDBSTPN020 195 36
30Amp TPN P l ug CSDBP TPN030 303 36
30Amp TPN Socke t CSDBSTPN030 303 36
PLUG AND SOCKET DBs
Plastic Enclosure without MCB
Descr ip t ion P roduc t Code MRP ( ` )
S P / D P C S D B M C B E P S P 103
T P / F P C S D B M C B E P T P 163
D e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o nD e s c r i p t i o n P r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d eP r o d u c t C o d e M R P M R P M R P M R P M R P ( ` )( ` )( ` )( ` )( ` )
SPN 04 way Tel & TV SOCKET DB ( 2+4) CSDBSPNTELTV04 1980
SPN 06 way Tel & TV SOCKET DB ( 2+6) CSDBSPNTELTV06 2100
SPN 08 way Tel & TV SOCKET DB ( 2+8) CSDBSPNTELTV08 2230
SPN 10 way Tel & TV SOCKET DB ( 2+10) CSDBSPNTELTV10 2370
SPN 12 way Tel & TV SOCKET DB ( 2+12) CSDBSPNTELTV12 2640
SPN 14 way Tel & TV SOCKET DB ( 2+14) CSDBSPNTELTV14 2725
TPN 04 way Tel & TV SOCKET DB (8+12) CSDBTPNTELTV04 3400
TPN 06 way Tel & TV SOCKET DB (8+18) CSDBTPNTELTV06 3900
TPN 08 way Tel & TV SOCKET DB (8+24) CSDBTPNTELTV08 4500
TPN 12 way Tel & TV SOCKET DB (8+36) CSDBTPNTELTV12 5860
Tel. & TV Socket DB
thPrice Schedule - Effective 19 April, 2011
Price SchedulethEffective 19 April, 2011
Low Voltage Components