8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 1/72
LANCERLANCEREVOLUTION VIIIEVOLUTION VIII
WARRANTYWARRANTY
AND MAINTENANCEAND MAINTENANCE
MANUALMANUAL
UNITED STATES AND
U.S. TERRITORIES & POSSESSIONS *
EXCEPT PUERTO RICO AND U.S. VIRGIN ISLANDS
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 2/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 3/72
IMPORTANT
This manual contains warranties for two markets: (a) The United States (territory covered by MMNA)and (b) U.S. territories and possessions except Puerto Rico and the U.S. Virgin lslands. Please readthe warranty that applies to your location.
(a) For the United States (territory covered by MMNA):
Limited warranty→ Refer to pages 2 to 28.
(b) For U.S. territories and possessions except Puerto Rico and the U.S. Virgin lslands:Limited warranty→ Refer to pages 29 to 35.
The maintenance schedule applies to both markets. Good maintenance is a great way to protect yourinvestment and ensure proper performance. For information on correct maintenance, refer to pages36 to 65.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 4/72
TABLE OF CONTENTS
For the United States (MMNA) Limited Warranty
Introduction .............................................. 2
Customer Satisfaction............................. 2 Warranty at a Glance .............................. 4
New Vehicle Limited Warranty ............... 6
10/100 Powertrain Limited Warranty ...... 9
Roadside Service and Towing ............. 11
Anti-Corrosion PerforationLimited Warranty.................................... 12
Federal Emission Warranty................... 14
Defect Warranty Performance Warranty
“California” Emission Warranty (California, Massachusetts, Vermont and Maine)...................................................... 18
Defect Warranty Performance Warranty
Notice to Consumers and Customer Satisfaction........................... 26
For U.S. territories and posses- sions Limited Warranty (Except Puerto Rico and U.S.Virgin Islands)
Mitsubishi New Vehicle Warranty .........29 Anti-Corrosion Perforation
Limited Warranty ...............................32 Emission Control System ......................33
Defect Warranty
Performance Warranty
Maintenance Service precautions ...............................36
Selecting the proper
maintenance schedule ...........................36 Emission control system maintenance............................................37
Service station checks...........................37
Regular maintenance schedule.............38
Severe maintenance schedule ..............51
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 5/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 6/72
INTRODUCTION
3
Should an Authorized Mitsubishi Motors Dealer charge forwarranty repairs, you should obtain a detailed receipt cov-ering the work performed and, upon returning to the U.S.,contact an Authorized Mitsubishi Motors Dealer for reim-bursement consideration.
IMPORTANT:
Vehicles operating outside of the U.S., its territories andpossessions are not covered under the terms of this limited
warranty.
NOTE
Vehicles registered in the United States, but temporarilytraveling in Canada or Puerto Rico are covered by theterms of this warranty and may be brought to Mitsubishidealers in Canada or Puerto Rico for warranty coveredrepairs.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 7/72
WARRANTY AT A GLANCE
4
NEW VEHICLE LIMITED WARRANTY
■ ■ ■ ■ ■ This time/mileage is covered under the New Vehicle Limited Warranty* Note: Applies only to the original owners of new, retailed vehicles.Subsequent owners receive 5 years/60,000 mile coverage.
Coverage12 months/ 3 years/ 5 years/ 7 years/ 10 years/
12,000 miles 36,000 miles 60,000 miles 100,000 miles 100,000 miles
New Vehicle Limited Coverage
10/100 Powertrain Coverage* *
Adjustments
Anti-corrosion
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 8/72
WARRANTY AT A GLANCE
5
EMISSION CONTROL SYSTEM WARRANTY
Coverage 2 years/ 3 years/ 3 years/ 5 years/ 7 years/ 8 years/ 15 years/
24,000 miles 36,000 miles 50,000 miles 60,000 miles 70,000 miles 80,000 miles 150,000 miles
Federal
Defect warranty
• Emission-related parts
• Engine Control Module, TransmissionControl Module, Catalytic Converter(s)and Onboard Emission DiagnosticDevice (OBD)
Performance warranty
• Emission-related parts
• Engine Control Module, TransmissionControl Module, Catalytic Converter(s)and Onboard Emission DiagnosticDevice
California,Massachusetts,Vermontand
Maine
Defect warranty
• Emission-related parts
• Long-term (1)
• Long-term (2)
• Galant 2.4 L PZEV model
Performance warranty
• Emission-related parts
• Long-term (1)
• Long-term (2)
• Galant 2.4 L PZEV model
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 9/72
NEW VEHICLE LIMITED WARRANTY
6
NEW VEHICLE
LIMITED WARRANTY
WHAT IS COVERED
NEW VEHICLE LIMITED WARRANTY COV-ERAGE AND TERM
MMNA warrants that all parts of this Vehicle supplied by MMNA(except batteries, adjustments required as a result of a manu-facturing deficiency, tires and items listed under the headings“OTHERS”, “ADDITIONAL COVERAGE”, and “WHAT IS NOTCOVERED”) are free from defects in materials or workmanshipat the time of delivery. If such a defect in materials or workman-ship appears during the first 5 years or 60,000 odometer miles,the part will be repaired or replaced by any Authorized Mitsub-ishi Motors Dealer or Authorized Service Center, using new orremanufactured Authorized Mitsubishi parts. The remedydescribed above shall be the sole and exclusive remedy forbreach of warranty, either express or implied.
NOTE
“New or Remanufactured Authorized Mitsubishi MotorsParts” when used in connection with Mitsubishi vehicles,means parts manufactured by or approved by Mitsubishi,designed for use on Mitsubishi vehicles and distributed byMMNA or any division or subsidiary of MMNA.
COVERAGE APPLICATION
This coverage applies to all owners of this Vehicle duringthe stated time and mileage limitations. This Limited War-ranty applies only to Mitsubishi passenger cars and sportutility vehicles that are registered in the United States andnormally operated in the United States or temporarily trav-eling in Canada or Puerto Rico.
BATTERYDuring the first 24 months from the vehicle’s in–servicedate, with unlimited mileage, a defective original equipmentbattery will be replaced free of charge.Should the battery fail after 24 months but before the 37thmonth of service, it will be replaced under warranty at a50% charge to customer. Labor to test, remove and install
the warranty replacement battery will be covered at 100%.A battery that is merely discharged is not considered to bedefective.
ADJUSTMENT PERIOD
Adjustments required as a result of a manufacturing defi-
ciency are covered for 12 months or 12,000 odometermiles, whichever occurs first.
OTHERS
The following factory installed items are covered underwarranty for 3 years or 36,000 odometer miles, whicheveroccurs first.
• Audio optic related parts on audio and navigation parts• Bulbs (All filament bulbs)
NOTE
Aftermarket parts or accessories not supplied orapproved by MMNA are NOT covered by this warranty.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 10/72
NEW VEHICLE LIMITED WARRANTY
7
Air Conditioner Refrigerant Charge
The air conditioner refrigerant charge is covered for 1 yearor 12,000 odometer miles, whichever comes first. Afterthat, refrigerant charge is only covered as part of a war-ranty covered repair to the air conditioning system.
TIRES
The tires on your new Mitsubishi vehicle are warranted
independently from this limited warranty by the individualtire manufacturer. The individual tire manufacturer’s war-ranty statement has been provided with your Vehicle. Toobtain tire warranty service, you must follow the proceduresoutlined in the tire warranty statement.
WHAT IS NOT COVERED
ALTERATION, MISUSE, OR ACCIDENT DAMAGE
Examples are:• Any vehicle previously declared a total loss and/or trans-
ferred or title branded as salvage, due to an accident orother catastrophic event
• Collision, fire, theft, freezing, vandalism, riot, explosion,
or objects striking your Vehicle• Misusing your Vehicle, such as, but not limited to, driving
over curbs, overloading, racing, or using your Vehicle asa stationary power source
• Alteration or modification of your Vehicle, including, butnot limited to, the body, chassis, braking system or othercomponents
• Tampering with, or modification to emission control sys-tems or with other parts that affect these systems
• Disconnecting or altering the odometer, where the actualmileage cannot be determined
• Contaminated or improper fuel/fluids• Damage due to customer-applied chemicals (For exam-
ple: abrasive waxes, polishes, sealants, etc.)
DAMAGE CAUSED BY USE AND/OR THE ENVIRON-
MENT
Examples are:• Air borne fallout• Industrial fallout• Chemicals• Acid rain• Tree sap• Bird droppings
• Sand• Salt• Stones• Road hazards• Hail• Insects• Lightning
• Floods
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 11/72
NEW VEHICLE LIMITED WARRANTY
8
DAMAGE CAUSED BY IMPROPER MAINTENANCE
OR FAILURE TO FOLLOW THE RECOMMENDED
MAINTENANCE SCHEDULE
The repair of damages, which are caused because parts orservices used were not those prescribed in this booklet’srecommended maintenance schedule, are not coveredunder warranty. It is the owner’s responsibility to maintainthe Vehicle as more fully set forth in, and in accordance
with, the maintenance schedules outlined in this booklet.Be advised that Warranty coverage may be denied if propermaintenance is not followed.
IMPORTANT- For Lancer Evolution Owners only :THE USE OF FULLY SYNTHETIC 10W-30
MOTOR OIL WITH THE ILSAC CERTIFI-
CATION SYMBOL IS REQUIRED.The Mitsubishi Lancer Evolution requires the use of fullysynthetic 10W-30 motor oil with the ILSAC certificationsymbol. Fully synthetic 10W-30 motor oil with the ILSACcertification symbol is required for all oil changes and forany oil added between oil changes.It is important that you:
DO NOT USE CONVENTIONAL PETROLEUM BASEDMOTOR OIL.
• DO NOT USE “BLENDS” OF CONVENTIONAL OILAND SYNTHETIC OIL.
• USE ONLY FULLY SYNTHETIC 10W-30 MOTOR OILWITH THE ILSAC CERTIFICATION SYMBOL.
NOTICE:
If you cannot find oils with the ILSAC certificationsymbol, use fully synthetic oil with an API classifica-tion SL, SL/CF or higher.
SAE 5W–30 fully synthetic engine oil can be used toimprove engine startability in very cold weatherareas where the lowest atmospheric temperature is
below –10°F (–23°C).
The use of conventional motor oils may cause engineor turbocharger damage that is not covered by yourwarranty.
If the approved SAE 10W–30 (or SAE 5W–30) fully syn-
thetic motor oil is not used, any oil related engine orturbocharger failure, along with any peripheral engineor powertrain damage, will not be considered a war-rantable condition.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 12/72
NEW VEHICLE LIMITED WARRANTY
9
MAINTENANCE / WEAR
Parts and labor needed to maintain the vehicle and thereplacement of parts due to normal wear and tear are notcovered by warranty and are the owner’s responsibility(unless those costs result from a warranty covered repair).Examples are:• Brake pads/shoes• Clutch disc facings
• Wiper blades• Lubrication• Engine tune-ups• Replacing filters, coolant or fuses• Replacing spark plugs• Cleaning and polishing
PAINT AND OTHER APPEARANCE ITEMSDefects in paint, trim or other appearance items are nor-mally noted and corrected during the new vehicle inspec-tion. For your protection, should you find any paint orappearance item which you suspect is defective, adviseyour Authorized Mitsubishi Motors Dealer without delay, asnormal deterioration due to use and exposure is not cov-
ered by this warranty.
OTHER
Incidental or consequential damages such as loss of use ofVehicle, loss of time, inconvenience, expense for gasoline,telephone, travel or lodging, loss or damage to personalproperty, commercial loss of revenue or other matters notspecifically included are not covered.
WARRANTY REPAIR ORDER
If you should have warranty service performed on this Vehi-cle, you are entitled to receive a copy of the repair orderlisting the warranty service performed. RETAIN THESECOPIES FOR YOUR RECORDS.Receipts covering the performance of maintenance ser-vices should be retained in the event questions arise con-cerning maintenance. These receipts should be transferred
to each subsequent owner of this vehicle. MMNA reservesthe right to deny warranty coverage if the vehicle has notbeen properly maintained. However, denial will not bebased solely on the absence of maintenance records.
PRODUCTION CHANGES
MMNA and its Authorized Mitsubishi Motors Dealers
reserve the right to make changes in Vehicles sold by themat any time without incurring any obligation to make thesame or similar changes on Vehicles previously sold bythem.
10-YEAR / 100,000 MILE POWERTRAIN LIM-
ITED WARRANTY COVERAGE & TERM
NOTE
Applies only to the original owner of all new, retailedvehicles. Subsequent owners receive the balance ofcoverage remaining under the 5-years/60,000 miles"New Vehicle Limited Warranty".
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 13/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 14/72
NEW VEHICLE LIMITED WARRANTY
11
• Balancer Shafts• Balancer Belt and Related Parts
• Oil Pan and Oil Pump• Intake Manifold• Water Pump• Fuel Pump• Flywheel or Drive Plate (Including Ring Gear)
TRANSAXLE/TRANSMISSION & TRANSFER CASE:
• Transaxle Case and All Internal Parts, Gaskets & Seals• Transmission Case and All Internal Parts, Gaskets &Seals
• Transfer Case and All Internal Parts, Gaskets and Seals• Torque Converter (Including Ring Gear)• Transaxle, Transmission and Transfer Case Mounts
OTHER POWERTRAIN COMPONENTS:
• Drive Shaft and Axle Shaft Assemblies (Including Con-stant Velocity Joints)
• Propeller Shaft Assemblies and Yokes (including Con-stant Velocity Joints and/or Universal Joints)
• Propeller Shaft Center Bearings• Axle Housing and All Internal Parts, Gaskets and Seals• Axle Shaft Bearings• Differential Carrier Assemblies and All Internal Parts,
Gaskets and Seals
WHAT IS NOT COVERED UNDER THIS 10-YEAR /
100,000 MILE POWERTRAIN LIMITED WARRANTY:
See the “New Vehicle Limited Warranty” section of thisbooklet for examples and further details of what is NOT
covered (Page 7).
ROADSIDE SERVICE- FOR 5 YEARS/UNLIM-ITED MILEAGE
Should you ever need it, you have access to 24-hour emer-
gency roadside services for five full years, regardless ofmileage. Covered services include towing (even in theevent of an accident), jump starts, flat-tire service, emer-gency fuel and fluid delivery and much more.
You are covered for:
• Towing to the nearest Mitsubishi Motors Retailer or other
approved service point if your vehicle is not driveable• Jump-starts in the event of a dead battery• Exchange of a flat tire with your inflated spare• Emergency fuel and fluid delivery• Lockout assistance to gain entry into your vehicle• Mechanical “first aid” for minor roadside repairs or adjust-
ments
CALL->1-888-MITSU-2005 (1-888-648-7820)
Roadside Service excludes winching of vehicles off road,vehicles disabled in rally, racing or other competitive eventsand vehicles used for commercial purposes such as police,taxi, route delivery, livery or daily rental services.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 15/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 16/72
NEW VEHICLE LIMITED WARRANTY
13
THINGS YOU SHOULD KNOW ABOUT YOUR MMNA
ANTI-CORROSION PERFORATION LIMITED WAR-
RANTY:
REPAIRING YOUR MITSUBISHI VEHICLE
If your Vehicle is damaged and requires sheet metal repairor replacement, be sure anti-corrosion materials areapplied to the parts repaired or replaced.
MAINTAINING YOUR MITSUBISHI VEHICLE
Washing:
The best way to preserve your Vehicle’s finish and aid inavoiding rust is to keep the Vehicle clean by washing it fre-quently. Wash the Vehicle only with lukewarm or cold water.Do not wash the Vehicle in the direct rays of the sun, or use
strong soap or chemical detergents. Any cleaning agentsused should be washed off promptly and not allowed to dryon the finish.
Foreign Material Deposits:
Calcium chloride and other salts, ice melting agents, roadoil and tar, tree sap, bird droppings, chemicals from indus-
trial chimneys, acid rain, and other foreign matter maydamage the Vehicle finish if left on the painted surfaces.Prompt washing may not completely remove all thesedeposits.Additional cleaners may be needed. When using chemicalcleaners developed for this purpose, be sure they are safefor use on painted surfaces.
Underbody Maintenance:
Corrosive materials used for ice removal and dust control
can collect on underbody surfaces. If these materials arenot removed, accelerated corrosion can occur on the under-body parts, such as fuel lines, frame, floor pan and exhaustsystem. At least twice a year, thoroughly flush these materi-als from the underbody with plain water. Take care to cleanany areas where mud and other debris can collect.
Finish Damage:Any stone chips, fractures or deep scratches in the finishshould be repaired promptly. Bare metal will corrodequickly and can develop into a major repair expense. Minorchips and scratches can be repaired with touch-up materi-als available from your Authorized Mitsubishi Motors Dealeror Authorized Service Center.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 17/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 18/72
FEDERAL EMISSION WARRANTY
15
If all the foregoing conditions are met, MMNA warrants thatany Authorized Mitsubishi Motors Dealer or Authorized
Service Center will replace, repair or adjust to Mitsubishi’sspecifications at no charge, any of the components listedbelow or parts thereof, which may be necessary to causeyour Vehicle to conform to the applicable emission stan-dards. Parts “Certified to EPA Standards” shall be coveredby this performance warranty. This performance warrantyperiod begins on the date of original retail delivery or origi-
nal use, whichever occurs first.
EMISSION WARRANTY PARTS
• Multiport Fuel Injection System• Electronic Spark Control• Timing Advance/Retard System• Evaporative Emission Canister, Evaporative Emission
Liquid Separator and Controls• Positive Crankcase Ventilation Valve• Induction Control Valve Assembly
• Exhaust Gas Recirculation Valve and Control System• Catalytic Converter(s)• Fuel Tank Filler Tube and Cap• Hoses, Clamps, Brackets, Pipes, Gaskets, Belts, Seals
and Connectors used in the above systems• Vacuum, Temperature, Altitude, Speed and Time Sensi-
tive Valves and Switches for the above systems
• Any other components necessary to assure conformity.• TurbochargerIf failure of one of these components results in failure ofanother part, both will be covered by the performance war-ranty.
WHAT IS NOT COVERED
• Noncompliance caused by defective replacement partsnot certified in accordance with aftermarket parts certifi-cation regulations.
• Noncompliance caused by the use of replacement partsnot equivalent to original equipment parts.
Other provisions specified under the “WHAT IS NOT COV-
ERED” section in the New Vehicle Limited Warranty arealso applicable to this warranty.
NOTE
Vehicles equipped with a California Certified EmissionControl System and registered in the states of California,Massachusetts, Vermont or Maine are also entitled to theCalifornia Emission Warranty. (See page 18 of this book-
let.)
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 19/72
FEDERAL EMISSION WARRANTY
16
THE EMISSION CONTROL SYSTEM DEFECT WAR-RANTY AND THE EMISSION CONTROL SYSTEM PER-
FORMANCE WARRANTY SHALL NOT APPLY TO:
• Conditions resulting from contaminated fuel, misuse,improper adjustments, modifications, accidents, alter-ations, tampering, acts of God, improper or inadequatemaintenance, or failure to use recommended fuel
• The replacement of maintenance parts used in regular
maintenance services• Loss of time, inconvenience, loss of use of the Vehicle, or
other consequential damages• Any Vehicle on which the odometer reading has been
changed so that mileage cannot be readily determined.
MMNA does not authorize any person to create for it anyother obligations or liability in connection with these sys-tems. These warranties are in addition to MMNA’s NewVehicle Limited Warranty for 2005 Vehicles.
THINGS YOU SHOULD KNOWABOUT BOTH THE EMIS-SION CONTROL SYSTEM DEFECT WARRANTY AND
THE EMISSION CONTROL SYSTEM PERFORMANCEWARRANTY
The emission control system of your new 2005 Mitsubishivehicle was designed, built and tested using AuthorizedMitsubishi Motors Parts and the Vehicle is certified asbeing in conformity with applicable emission regulations.
Accordingly, it is recommended that any replacement partsused for maintenance or for the repair of emission controlsystems be new or remanufactured Authorized MitsubishiMotors Parts.
THE WARRANTY OBLIGATIONS ARE NOT DEPENDENTUPON THE USE OF ANY PARTICULAR BRAND OFREPLACEMENT PART. THE OWNER MAY ELECT TOUSE NON-AUTHORIZED MITSUBISHI MOTORS PARTSFOR REPLACEMENT PURPOSES. THE USE OFREPLACEMENT PARTS WHICH ARE NOT EQUIVALENTMAY IMPAIR THE EFFECTIVENESS OF EMISSION CON-TROL SYSTEMS.
If other than Authorized Mitsubishi Motors Parts are usedfor maintenance replacements or for the repair of compo-nents affecting emission control, the owner should deter-mine that such parts are warranted by the manufacturer tobe equivalent to Authorized Mitsubishi Motors Parts in per-formance and durability.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 20/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 21/72
“CALIFORNIA” EMISSION WARRANTY
18
FOR ALL JURISDICTIONS THAT HAVE ADOPTED
CALIFORNIA EMISSION CONTROL SYSTEMS AND
WARRANTY REQUIREMENT.
“CALIFORNIA” EMISSION
WARRANTY
YOUR WARRANTY RIGHTS AND OBLIGATIONSThe California Air Resources Board and Mitsubishi MotorsNorth America, Inc. (MMNA) are pleased to explain theemission control system warranty on your 2005 Mitsubishivehicle.In California, Massachusetts, Vermont, Maine and New
York*1, new motor vehicles must be designed, built and
equipped to meet California’s stringent anti-smog stan-dards.
*1: 2005 model year vehicles sold in New York will be covered by the
Federal Emission Warranty.
MMNA warrants the emission control system on your Vehi-
cle for the periods of time listed below, provided there hasbeen no abuse, neglect or improper maintenance of yourVehicle.Your emission control system may include parts such asthe fuel-injection system, the ignition system, catalytic con-verter, and engine control module. Also included may behoses, belts, connectors and other emission-related
assemblies.
Where a warrantable condition exists, MMNA will repairyour Vehicle at no charge to you including diagnosis, parts
and labor.
MANUFACTURER’S WARRANTY COVERAGE:
1. For 3 years or 50,000 odometer miles, whicheveroccurs first:
(1) If your Vehicle fails a Smog Check inspection, all nec-
essary repairs and adjustments will be made by MMNAto ensure that your Vehicle passes the inspection. Thisis your emission control system PERFORMANCEWARRANTY.
(2) For 5 years or 60,000 odometer miles, whicheveroccurs first: if any emission-related part on your Vehicleis defective, the part will be repaired or replaced by
MMNA.This is your short-term emission control systemDEFECTS WARRANTY.
2. For 7 years or 70,000 odometer miles, whicheveroccurs first:
If your vehicle fails a Smog Check inspection due to adefect in an emmission-related part specially noted in thiswarranty booklet with coverage for 7 years or 70,000 odom-eter miles, the part will be repaired or replaced by MMNA.This is your Long-term (1) emission control systemDEFECTS WARRANTY.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 22/72
“CALIFORNIA” EMISSION WARRANTY
19
3. For 8 years or 80,000 odometer miles, whicheveroccurs first, the Federal Emission Warranty also
applies to Vehicles registered in California, Massachu-setts, Vermont and Maine:
If an emission-related part listed in this warranty book-let specially noted with coverage for 8 years or 80,000odometer miles is defective, the part will be repaired orreplaced by MMNA. This is your Long Term (2) emis-
sion control system PERFORMANCE and DEFECTSWARRANTY.
4. For the 2005 Mitsubishi Galant 2.4 L PZEV model, allemissions defects and performance warranties areextended to 15 years or 150,000 miles, whicheveroccurs first.
OWNER’S WARRANTY RESPONSIBILITIES:As the Vehicle owner, you are responsible for the perfor-mance of the required maintenance listed in this booklet.MMNA recommends that you retain all receipts coveringmaintenance on your Vehicle. Coverage will not be deniedsolely because there is no record of maintenance. How-ever, failures caused by lack of required maintenance are
covered by the warranty.
You are responsible for presenting your Vehicle to anAuthorized Mitsubishi Motors Dealer or Authorized ServiceCenter as soon as a problem exists.
The warranty repairs should be completed in a reasonableamount of time, not to exceed 30 days.
As the Vehicle owner, you should also be aware thatMMNA may deny you warranty coverage if your Vehicle ora part has failed due to abuse, neglect, improper mainte-nance or unapproved modifications.
If you have any questions regarding your warranty rightsand responsibilities, you should contact MMNA’s Customer
Relations Department at 1-888-MITSU-2005 (1-888-648-7820) or if in California, the California Air Resources Board,P.O. Box 8001 at 9528 Telstar Avenue, EL Monte CA91734-8001.
WARRANTY START DATE:
The 3-years/50,000 odometer miles, 5-years/60,000 odom-
eter miles, 7-years/70,000 odometer miles, 8-years/80,000odometer miles and 15-years/150,000 odometer miles war-ranty periods shall begin on the date of original retail deliv-ery or original use, whichever occurs first.
not covered by warranty.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 23/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 24/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 25/72
“CALIFORNIA” EMISSION WARRANTY
22
Listed below is an additional part warranted against defectsin materials and workmanship for 7 years or 70,000 odom-
eter miles, whichever occurs first, for the Eclipse/EclipseSpyder 3.0L.
• Distributor
Listed below is an additional part warranted against defectsin materials and workmanship for 7 years or 70,000 odom-
eter miles, whichever occurs first, for the Lancer, LancerEvolution, Galant 2.4L, Eclipse/Eclipse Spyder, and Out-lander.
• Intake Manifold
Listed below is an additional part warranted against defects
in materials and workmanship for 7 years or 70,000 odom-eter miles, whichever occurs first, for the Eclipse/EclipseSpyder 3.0 L.
• Exhaust Pipe(s) between Exhaust Manifold(s) and Cata-lytic Converter(s)
Listed below is an additional part warranted against defectsin materials and workmanship for 7 years or 70,000 odom-eter miles, whichever occurs first, for the Lancer Evolution,Eclipse/Eclipse Spyder 2.4L, Galant and Endeavor.
• Exhuast Manifold(s)
Listed below is an additional part warranted against defectsin materials and workmanship for 7 years or 70,000 odom-
eter miles, whichever occurs first, for the Eclipse/EclipseSpyder.
• Air Flow Sensor
Listed below is an additional part warranted against defectsin materials and workmanship for 7 years or 70,000 odom-
eter miles, whichever occurs first, for the Lancer Evolution.
• Turbocharger
Listed below is an additional part warranted against defectsin materials and workmanship for 7 years or 70,000 odom-eter miles, whichever occurs first, for the Lancer, Lancer
Evolution, Galant 2.4L, Outlander 2.4L MPI, Montero andMontero Sport.
• Throttle Body
Listed below is an additional part warranted against defectsin materials and workmanship for 7 years or 70,000 odom-eter miles, whichever occurs first, for all models.
• Fuel Tank
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 26/72
“CALIFORNIA” EMISSION WARRANTY
23
Listed below are additional parts warranted against defectsin materials and workmanship for 8 years or 80,000 odom-
eter miles, whichever occurs first, for all models.
• Engine Control Module (including OBD II)• Transmission Control Module (including OBD II)• Catalytic Converter(s)• Onboard Emission Diagnostic Device
Listed below are parts warranted against defects in materi-als and workmanship for 15 years or 150,000 miles, which-ever occurs first for the Galant 2.4 L PZEV model.
• All emissions control parts
WHAT THE OWNER MUST DO:
It is the owner’s responsibility to have the required mainte-
nance performed and use the Vehicle in accordance withMMNA’s written instructions. Coverage WILL NOT bedenied solely because there is no record of maintenance.However, failures caused by lack of required maintenanceare not covered by the warranty. To avoid questions as towhether the vehicle maintenance has been performed,MMNA urges that the owner retain all receipts and/or main-tenance records’ indicating that service has been per-formed on the vehicle and these receipts and maintenancerecords should be transferred to any subsequent owner ofthe vehicle.
SERVICE:
MAINTENANCE SERVICE CAN BE PERFORMED BYANY QUALIFIED SERVICE OUTLET OR BY THE OWNEROR BY SOMEONE OF THE OWNER’S CHOOSING.HOWEVER, WARRANTY SERVICE MUST BE PER-FORMED BY AN AUTHORIZED MITSUBISHI MOTORSDEALER OR SERVICE CENTER, IN ORDER TO BE PER-FORMED AT NO CHARGE TO YOU.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 27/72
“CALIFORNIA” EMISSION WARRANTY
24
PARTS:
IT IS RECOMMENDED THAT ANY REPLACEMENT
PARTS USED FOR MAINTENANCE OR FOR THEREPAIR OF THE EMISSION CONTROL SYSTEMS BENEW OR REMANUFACTURED, AUTHORIZED MITSUB-ISHI MOTORS PARTS.
However, the warranty obligations ARE NOT dependentupon the use of any particular brand of replacement parts.The owner may elect to use non-Authorized MitsubishiMotors Parts for replacement purposes. Use of replace-ment parts which are not of equivalent quality to AuthorizedMitsubishi Motors Parts may impair the effectiveness ofemission control systems.
WHAT IS NOT COVERED:
The Warranty does not cover:
• Malfunction in any part caused by abuse, misuse, alter-ation, tampering, disconnection or improper or inade-quate maintenance.
• Damage to catalytic converters or oxygen sensors due touse of leaded gasoline or any additives.
• Damage resulting from fire, accident, negligence, acts ofGod or other events beyond the control of MMNA.
• Maintenance replacement parts (such as spark plugs)beyond the first scheduled replacement point.
• Incidental or consequential damages such as loss of useof the vehicle, loss of time, inconvenience, expenses forgasoline, telephone, travel or lodging.
• Any vehicle on which the odometer mileage has beenaltered so that actual vehicle mileage cannot readily bedetermined.
• Loss or damage to personal property, loss of revenue,commercial loss.
• Damages resulting from a defect in a part not designatedby MMNA; see owner responsibilities stated above.
NOTE
“New or Remanufactured Authorized Mitsubishi MotorsParts” when used in connection with Mitsubishi vehicles,means parts manufactured by or approved by MITSUB-ISHI, designed for use on Mitsubishi vehicles and distrib-uted by MMNA or any division or subsidiary of MMNA.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 28/72
“CALIFORNIA” EMISSION WARRANTY
25
EMERGENCY SERVICE:
If emergency emission control system warranty service is
required and the owner is unable to readily locate anAuthorized Mitsubishi Motors Dealer or Authorized ServiceCenter or if a warranted part is not available within 30 days,then, repairs may be performed at any available serviceestablishment, or by the owner, using any replacementpart.MMNA will reimburse the owner for the owner’s expensesincluding diagnostic charges for such emergency repair orreplacement at MMNA’s suggested retail price for all war-ranted parts replaced and labor charges based on theMMNA’s recommended time allowance for the warrantyrepair and the geographically appropriate hourly labor rate.Replaced parts and copies of paid original receipts must beavailable for presentation to MMNA as a condition of reim-bursement for these emergency repairs. In addition, theowner must provide MMNA a detailed description indicat-ing why the situation was considered an emergency andwhy an Authorized Mitsubishi Motors Dealer or AuthorizedService Center was not available. Additional informationmay be obtained by calling 1-888-MITSU-2005 (1-888-648-
7820). A repair not being completed within 30 days due tothe inability to obtain a warranted part or the unavailabilityof an authorized Mitsubishi Motors Dealer or AuthorizedService Center constitutes an emergency.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 29/72
NOTICE TO CONSUMERS
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 30/72
NOTICE TO CONSUMERS
27
or replacement vehicle. Therefore, MMNA requests that youfirst provide us with written notification of any such non confor-
mities, so that we may have an opportunity to make finalrepairs to the vehicle before you pursue lemon law remedies.There may be times when MMNA will pay all or part of the costof certain repairs beyond the terms of the warranty. Check withyour local dealer to determine if this applies to your vehicle.
Wisconsin Vehicle Owners: In the state of Wisconsin, you
must use NCDS prior to seeking remedies available to youthrough a court action pursuant to the Magnuson-Moss War-ranty Act. In addition, you must use NCDS prior to seekingremedies under the Wisconsin Lemon Law.For further information contact: WisDot Dealer Section / P.O.Box 7909 / Madison / WI / 53707-7909 / 608-266-1425 /[email protected].
OTHER TERMS
ANY IMPLIED WARRANTY APPLICABLE TO THIS VEHI-CLE IS LIMITED IN DURATION TO THE LENGTH OFTHIS WRITTEN WARRANTY. MMNA SHALL NOT BE LIA-BLE FOR ANY INCIDENTAL, CONSEQUENTIAL, SPE-CIAL OR EXEMPLARY DAMAGES FOR BREACH OFTHIS WARRANTY OR ANY IMPLIED WARRANTY.
Some states do not allow the exclusion or limitation of inci-dental or consequential damages or limitation on how longan implied warranty lasts, or limitations on available reme-dies, so the above limitations or exclusions may not apply toyou. This warranty gives the owner specific legal rights and
the owner may also have other rights which vary by state.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 31/72
U S territories and possessions (Except Puerto Rico and U S Virgin Islands)
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 32/72
U.S. territories and possessions (Except Puerto Rico and U.S. Virgin Islands)
29
MITSUBISHI NEW VEHICLE WARRANTYMITSUBISHI warrants to the owner of each New 2005 MITSUBISHI passenger car and sport utility vehicle (hereinafter referred to as “Vehicles”) that the MITSUBISHI vehicles,and any part of the Vehicles (except batteries, tires, adjustment and items listed under the headings “OTHERS”, “ADDITIONAL COVERAGE” and “WHAT IS NO T COVERED”)
shall be free, under normal use and maintenance, from defects in material and workmanship, subject to the following terms and conditions:
WARRANTY START DATEThis warranty starts on the date of original retail delivery or original use, whichever occurs first.
OBTAINING WARRANTY SERVICETo obtain warranty service, you must return your Vehicle to any Authorized Mitsubishi Motors Dealer or Authorized Service Center where such service will be performedwithout charge for parts and/or labor.
OBTAINING WARRANTY SERVICE IN U.S.When a Vehicle purchased in the United States territories or possessions is registered in U.S., the Mitsubishi warranty in U.S. will apply. In the event you are temporarily travelingin U.S. (e.g. vacation), the warranty issued with this Vehicle will apply and warranty service will be provided by an Authorized Mitsubishi Motors Dealer in U.S..Should an Authorized Mitsubishi Motors Dealer charge for warranty repairs, you should obtain a detailed receipt covering the work performed and, upon return home, contact theselling Authorized Mitsubishi Motors Dealer for reimbursement consideration.
NEW VEHICLE LIMITED WARRANTY
EMISSION CONTROL SYSTEM WARRANTY
Coverage 12 months/ 3 years/ 5 years/ 7 years/
12,000 miles 36,000 miles 60,000 miles 100,000 miles
New Vehicle Limited Coverage
Adjustments
Anti-corrosion
Coverage 2 years/ 3 years/ 3 years/ 5 years/ 7 years/ 8 years/
24,000 miles 36,000 miles 50,000 miles 60,000 miles 70,000 miles 80,000 miles
Defect warranty
•Emission-related parts
•Engine Control Module, TransmissionControl Module, Catalytic Converter(s)and Onboard Emission Diagnostic Device
Performance warranty
•Emission-related parts
•Engine Control Module, TransmissionControl Module, Catalytic Converter(s)and Onboard Emission Diagnostic Device
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 33/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 34/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 35/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 36/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 37/72
U.S. territories and possessions (Except Puerto Rico and U.S. Virgin Islands)
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 38/72
p ( p g )
35
To obtain warranty service under these warranties, the owner should return the Vehi-cle to an Authorized Mitsubishi Motors Dealer or Authorized Service Center wheresuch service will be performed at no charge for parts and labor.
If an owner’s warranty claim under the 2005 Emission Control Systems PerformanceWarranty is denied, MITSUBISHI will provide the owner with a written explanation ofwhy the claim was denied within 30 days unless a shorter time period is required bylaw. Failure to provide an explanation within the required period may obligate MIT-SUBISHI to remedy the nonconformity under the Emission Control Systems Perfor-mance Warranty except:
* When delay is requested by the vehicle owner.* When delay is caused by factors beyond the control of MITSUBISHI or Authorized
Mitsubishi Motors Dealers or Authorized Service Centers.Further information can be obtained from and complaints registered with:Manager, Vehicle Compliance Programs Group
Vehicle Programs and Compliance DivisionEnvironmental Protection Agency401 “M” Street, S.W.NMS-6405JWashington, D.C. 20460
IF YOU HAVE ANY QUESTIONSMITSUBISHI and Authorized Mitsubishi Motors Dealers are vitally interested in yoursatisfaction with our products and service.In the event a warranty or any other matter is not handled to your satisfaction, pleasediscuss the matter with your Mitsubishi Motors Dealer Management.
NOTE“New or Remanufactured Authorized Mitsubishi Motors Parts” when used in con-nection with MITSUBISHI Vehicles, means parts manufactured by or approved byMITSUBISHI, designed for use on MITSUBISHI Vehicles and distributed by MIT-SUBISHI or any division or subsidiary of MITSUBISHI.
Maintenance
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 39/72
36
Service precautions
Vehicle maintenance is an important yet frequentlyneglected item. Proper maintenance will aid in retaining thelevel of performance that has been engineered into yourMitsubishi vehicle and it will guard against major repairexpenses resulting from neglect. Good maintenance is agreat way to protect your investment and ensure properperformance.
Your Mitsubishi Motors Dealership is in the best position toprovide proper maintenance service through Mitsubishi’sexclusive “Diamond Care Service”.
• Factory Trained Technicians• Advanced Diagnostic Equipment• Quality Workmanship
• Mitsubishi Genuine parts• Mitsubishi Authorized Accessories• Competitive Prices• Fast Service• Commitment to Customer Satisfaction
Selecting the proper maintenance
scheduleThere are two maintenance schedules that show properservice for your vehicle.
Regardless of which maintenance schedule you follow, theuse of fully synthetic motor oil is required. See “Engine Oil
and Filter” in the Owner’s Manual for details on motor oilrequirements.
First is “Regular maintenance schedule”.Follow the Regular maintenance schedule only if none ofthe driving conditions in the Severe maintenance sectionapply.
Second is “Severe maintenance schedule”.Follow the severe maintenance schedule only if your vehi-cle is frequently driven under one or more of the followingroad conditions.
• Driving on dusty, rough, muddy or salt-spread roads
• Towing or police, taxi or commercial operation• Extensive idling and /or low speed operation• Repeated short-trip operation at freezing temperatures
(engine not thoroughly warmed up)• Extended use of brakes while driving• Driving in sandy areas• More than 50% operation in heavy city traffic during hot
weather above 90°F (32°C)
Maintenance
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 40/72
37
Emission control system mainte-nance
The “scheduled” maintenance services, listed in bold typemust be done at the times or mileages specified to assurethe continued proper functioning of the emission control
system. These, and all other maintenance servicesincluded in this manual, should be done to provide the bestvehicle performance and reliability. More frequent mainte-nance may be needed for vehicles in severe operating con-ditions such as dusty areas and very short trip driving.Inspection and service also should be done any time a mal-function is suspected.
Service station checks
The following items should be inspected by either you or aservice station attendant each time fuel is added:
• Engine oil level. Add if needed. Check Owner’s Manual-See index and look under “Engine Oil” for detailed infor-mation.
• Engine coolant level. Add coolant to reservoir tank alongwith the proper mix if needed. Replace coolant if dirty orrusty in color. Check Owner’s Manual-See index and lookunder “Coolant” for detailed information.
• Windshield washer fluid level. Add fluid to washer tank ifnecessary.
• Tire inspection. Inspect for unusual tire wear and properinflation. Check Owner’s Manual-See index and lookunder “Tire” for detailed information.
CALIFORNIA, MASSACHUSETTS, VERMONT andMAINE ONLY:Regular maintenance schedules; replace air cleaner filterat 15,000 mile intervals and replace timing belt, balancerbelt (if equipped on your vehicle) at 60,000 mile intervals.These are recommended but are not required to maintainthe emissions warranty.
FEDERAL:Regular maintenance schedules; check fuel system forleaks, check fuel hoses condition, check and serviceexhaust system at 30,000 mile intervals.These are recommended but are not required to maintainthe emission warranty.
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 41/72
38
Regular maintenance schedule
Mileage or Time-Whichever occurs first
Enter Your Original In-Service Date Here:
Month Day Year
Original In-Service Date
● 5,000 Miles (8,000km) or at 5 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear. Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 10,000 Miles (16,000km) or at 10 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 42/72
39
Mileage or Time-Whichever occurs first
● 15,000 Miles (24,000km) or at 15 months
Replace air cleaner filter. *1
*1For California,Massachusetts,Vermont and Maine,this maintenance is recommended but is notrequired to maintain the emissions warranty.
Change engine oil.
Replace engine oil filter.
Check manual transaxle oil level and condition.
Check transfer oil level.
Check reserve tank fluid level
(for Active Center Differential).
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATE REPAIRORDER #
● 20,000 Miles (32,000km) or at 20 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 25,000 Miles (40,000km) or at 25 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 43/72
40
Mileage or Time-Whichever occurs first
● 30,000 Miles (48,000km) or at 30 months
Check fuel system for leaks *2
(tank, pipe line and connection, and fuel tank filler
tube cap).
*2 This maintenance is recommended but is notrequired to maintain the emissions warranty.
Check fuel hoses condition. *2
Replace air cleaner filter.
Replace drive belts (for the generator, water pump,
power steering pump).
Check and service exhaust system *2
(connection portion of muffler, muffler pipes and
converter heat shields). Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential). Change engine coolant.
Inspect coolant hoses condition.
(radiator hose, heater hose)
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Change rear axle oil, with Limited Slip Diff.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATE REPAIRORDER #
● 35,000 Miles (56,000km) or at 35 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE DATE
REPAIRORDER #
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 44/72
41
Mileage or Time-Whichever occurs first
● 40,000 Miles (64,000km) or at 40 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 45,000 Miles (72,000km) or at 45 months
Replace air cleaner filter.
Change engine oil.
Replace engine oil filter.
Check manual transaxle oil level and condition.
Check transfer oil level.
Check reserve tank fluid level
(for Active Center Differential). Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage. Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 45/72
42
Mileage or Time-Whichever occurs first
● 50,000 Miles (80,000km) or at 50 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 55,000 Miles (88,000km) or at 55 months Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 60,000 Miles (96,000km) or at 60 months
Check fuel system for leaks(tank, pipe line and connection, and fuel tank filler
tube cap).
Check fuel hoses condition.
Replace air cleaner filter.
Check evaporative emission control system for
leaks and clogging (except evaporative emission
canister).
Replace spark plugs,iridium-tipped type.
Replace timing belt *1
*1 For California,Massachusetts,Vermont and Maine,this maintenance is recommended but is not
required to maintain the emissions warranty. Replace drive belts (for the generator, water pump,
power steering pump).
Check and service exhaust system
(connection portion of muffler, muffler pipes and
converter heat shields).
Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential).
Change engine coolant.
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 46/72
43
Mileage or Time-Whichever occurs first Replace coolant hoses.
(radiator hose, heater hose)
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Change rear axle oil, with Limited Slip Diff.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 65,000 Miles (104,000km) or at 65 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 70,000 Miles (112,000km) or at 70 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 47/72
44
Mileage or Time-Whichever occurs first
● 75,000 Miles (120,000km) or at 75 months
Replace air cleaner filter.
Change engine oil.
Replace engine oil filter.
Check manual transaxle oil level and condition.
Check transfer oil level.
Check reserve tank fluid level
(for Active Center Differential).
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 80,000 Miles (128,000km) or at 80 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 85,000 Miles (136,000km) or at 85 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 48/72
45
Mileage or Time-Whichever occurs first
● 90,000 Miles (144,000km) or at 90 months
Check fuel system for leaks
(tank, pipe line and connection, and fuel tank filler
tube cap).
Check fuel hoses condition.
Replace air cleaner filter.
Replace drive belts (for the generator, water pump,
power steering pump).
Check and service exhaust system(connection
portion of muffler, muffler pipes and converter heat
shields).
Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential).
Change engine coolant.
Inspect coolant hoses condition.
(radiator hose, heater hose)
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Change rear axle oil, with Limited Slip Diff. Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 95,000 Miles (152,000km) or at 95 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage. Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 49/72
46
Mileage or Time-Whichever occurs first
● 100,000 Miles (160,000km) or at 100 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 105,000 Miles (168,000km) or at 105 months
Replace air cleaner filter.
Replace timing belt. *3
*3 This maintenance is not required if previouslyreplaced.
Change engine oil.
Replace engine oil filter.
Check manual transaxle oil level and condition. Check transfer oil level.
Check reserve tank fluid level
(for Active Center Differential).
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for greaseleaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/
MONTHS
DEALERSHIP
NAME/CODE
DATEREPAIR
ORDER #
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 50/72
47
Mileage or Time-Whichever occurs first
● 110,000 Miles (176,000km) or at 110 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 115,000 Miles (184,000km) or at 115 months Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 120,000 Miles (192,000km) or at 120 months
Check fuel system for leaks
(tank, pipe line and connection, and fuel tank filler
tube cap).
Check fuel hoses condition.
Replace air cleaner filter.
Check evaporative emission control system for
leaks and clogging (except evaporative emission
canister).
Replace spark plugs,iridium-tipped type.
Replace timing belt *4
*4 In case of replaced at 60,000 miles/60 months. Replace drive belts (for the generator, water pump,
power steering pump). Check and service exhaust system
(connection portion of muffler, muffler pipes and
converter heat shields).
Change engine oil.
Replace engine oil filter.
Change manual transaxle oil. Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential).
Change engine coolant.
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 51/72
48
Mileage or Time-Whichever occurs first
Replace coolant hoses.
(radiator hose, heater hose)
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Change rear axle oil, with Limited Slip Diff.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● at 120 months
Inspect SRS *5 airbag system.
*5 : Supplemental Restraint System
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 125,000 Miles (200,000km) or at 125 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/ MONTHS DEALERSHIPNAME/CODE DATE REPAIRORDER #
● 130,000 Miles (208,000km) or at 130 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 52/72
49
Mileage or Time-Whichever occurs first
● 135,000 Miles (216,000km) or at 135 months
Replace air cleaner filter.
Change engine oil.
Replace engine oil filter.
Check manual transaxle oil level and condition.
Check transfer oil level.
Check reserve tank fluid level
(for Active Center Differential).
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 140,000 Miles (224,000km) or at 140 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 145,000 Miles (232,000km) or at 145 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Regular Maintenance Schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 53/72
50
Mileage or Time-Whichever occurs first
● 150,000 Miles (240,000km) or at 150 months
Check fuel system for leaks
(tank, pipe line and connection, and fuel tank filler
tube cap).
Check fuel hoses condition.
Replace air cleaner filter.
Replace drive belts (for the generator, water pump,
power steering pump).
Check and service exhaust system(connection
portion of muffler, muffler pipes and converter heat
shields).
Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential).
Change engine coolant.
Inspect coolant hoses condition.
(radiator hose, heater hose)
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Change rear axle oil, with Limited Slip Diff.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Severe maintenance schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 54/72
51
Severe maintenance schedule
Mileage or Time-Whichever occurs first
● 3,750 Miles (6,000km) or at 4 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 7,500 Miles (12,000km) or at 8 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 11,250 Miles (18,000km) or at 12 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Mil Ti Whi h fi t
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 55/72
52
Mileage or Time-Whichever occurs first
● 15,000 Miles (24,000km) or at 16 months
Replace air cleaner filter.
Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential).
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 18,750 Miles (30,000km) or at 20 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 22,500 Miles (36,000km) or at 24 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Mil Ti Whi h fi t
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 56/72
53
Mileage or Time-Whichever occurs first
● 26,250 Miles (42,000km) or at 28 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 30,000 Miles (48,000km) or at 32 months
Check fuel system for leaks
(tank, pipe line and connection, and fuel tank filler
tube cap).
Check fuel hoses condition.
Replace air cleaner filter.
Replace drive belts (for the generator, water pump,
power steering pump).
Check and service exhaust system
(connection portion of muffler, muffler pipes and
converter heat shields).
Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential).
Change engine coolant.
Inspect coolant hoses condition.
(radiator hose, heater hose)
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Severe maintenance schedule
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 57/72
54
Mileage or Time-Whichever occurs first
Inspect drive shaft boots for grease leaks and damage.
Change rear axle oil, with Limited Slip Diff.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 33,750 Miles (54,000km) or at 36 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 37,500 Miles (60,000km) or at 40 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 41,250 Miles (66,000km) or at 44 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Mileage or Time Whichever occurs first
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 58/72
55
Mileage or Time-Whichever occurs first
● 45,000 Miles (72,000km) or at 48 months
Replace air cleaner filter.
Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential).
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 48,750 Miles (78,000km) or at 52 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 52,500 Miles (84,000km) or at 56 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Mileage or Time-Whichever occurs firstC i ( i
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 59/72
56
Mileage or Time Whichever occurs first
● 56,250 Miles (90,000km) or at 60 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 60,000 Miles (96,000km) or at 64 months Check fuel system for leaks
(tank, pipe line and connection, and fuel tank filler
tube cap).
Check fuel hoses condition.
Replace air cleaner filter.
Check evaporative emission control system forleaks and clogging (except evaporative emission
canister).
Replace spark plugs,iridium-tipped type.
Replace timing belt.
Replace drive belts (for the generator, water pump,
power steering pump).
Check and service exhaust system (connection
portion of muffler, muffler pipes and converter heat
shields).
Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential).
Change engine coolant.
Replace coolant hoses.
(radiator hose, heater hose)
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Change rear axle oil, with Limited Slip Diff.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Mileage or Time-Whichever occurs firstii
● 71 250 Mil (114 000k ) t 76 th
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 60/72
57
Mileage or Time Whichever occurs first
● 63,750 Miles (102,000km) or at 68 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 67,500 Miles (108,000km) or at 72 months Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires. Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 71,250 Miles (114,000km) or at 76 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Mileage or Time-Whichever occurs first● 78 750 Miles (126 000km) or at 84 months
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 61/72
58
Mileage or Time Whichever occurs first
● 75,000 Miles (120,000km) or at 80 months
Replace air cleaner filter.
Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential).
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 78,750 Miles (126,000km) or at 84 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 82,500 Miles (132,000km) or at 88 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 62/72
Severe maintenance schedule
e-hic
Inspect drive shaft boots for grease leaks and damage ● 97 500 Miles (156 000km) or at 104 months
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 63/72
60
Mileage or Time-Whichever occurs first
Inspect drive shaft boots for grease leaks and damage.
Change rear axle oil, with Limited Slip Diff.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 93,750 Miles (150,000km) or at 100 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 97,500 Miles (156,000km) or at 104 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 101,250 Miles (162,000km) or at 108 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Mileage or Time-Whichever occurs first● 108 750 Miles (174 000km) or at 116 months
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 64/72
61
● 105,000 Miles (168,000km) or at 112 months
Replace air cleaner filter. Replace timing belt.
Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level(for Active Center Differential).
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage. Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 108,750 Miles (174,000km) or at 116 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 112,500 Miles (180,000km) or at 120 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Mileage or Time-Whichever occurs firstfirst
● 120,000 Miles (192,000km) or at 128 months
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 65/72
62
● at 120 months
Inspect SRS *5 airbag system.
*5 : Supplemental Restraint System
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 116,250 Miles (186,000km) or at 124 months
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage. Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 120,000 Miles (192,000km) or at 128 months
Check fuel system for leaks
(tank, pipe line and connection, and fuel tank fillertube cap).
Check fuel hoses condition.
Replace air cleaner filter.
Check evaporative emission control system for leaks
and clogging (except evaporative emission canister).
Replace spark plugs,iridium-tipped type.
Replace timing belt.
Replace drive belts (for the generator, water pump,
power steering pump).
Check and service exhaust system (connection
portion of muffler, muffler pipes and converter heat
shields). Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential).
Change engine coolant.
Replace coolant hoses.
(radiator hose, heater hose)
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Severe maintenance schedule
Inspect ball joint and steering linkage seals for grease ● 127,500 Miles (204,000km) or at 136 months
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 66/72
63
Mileage or Time-Whichever occurs firstii
p j g g g
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Change rear axle oil, with Limited Slip Diff.
Rotate tires.
Replace air purifier filter.
MILEAGE/
MONTHS
DEALERSHIP
NAME/CODE DATE
REPAIR
ORDER #
● 123,750 Miles (198,000km) or at 132 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
, ( , )
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 131,250 Miles (210,000km) or at 140 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Mileage or Time-Whichever occurs first● 138,750 Miles (222,000km) or at 148 months
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 67/72
64
● 135,000 Miles (216,000km) or at 144 months
Replace air cleaner filter. Change engine oil.
Replace engine oil filter.
Change manual transaxle oil.
Change transfer oil.
Check reserve tank fluid level
(for Active Center Differential). Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
, ( , )
Change engine oil.
Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 142,500 Miles (228,000km) or at 152 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
Severe maintenance schedule
Mileage or Time-Whichever occurs firste-hic
Change manual transaxle oil.
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 68/72
65
Mileage or Tim
● 146,250 Miles (234,000km) or at 156 months
Change engine oil. Replace engine oil filter.
Inspect disc brake pads and rotors for wear.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Rotate tires.
Inspect air purifier filter for clogging.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
● 150,000 Miles (240,000km) or at 160 months Check fuel system for leaks
(tank, pipe line and connection, and fuel tank filler
tube cap).
Check fuel hoses condition.
Replace air cleaner filter.
Replace drive belts (for the generator, water pump,power steering pump).
Check and service exhaust system
(connection portion of muffler, muffler pipes and
converter heat shields).
Change engine oil.
Replace engine oil filter.
Change transfer oil.
Check reserve tank fluid level(for Active Center Differential).
Change engine coolant.
Inspect coolant hoses condition.
(radiator hose, heater hose)
Inspect disc brake pads and rotors for wear.
Check brake hoses for deterioration or leaks.
Inspect ball joint and steering linkage seals for grease
leaks and damage.
Inspect suspension system for looseness and damage.
Inspect drive shaft boots for grease leaks and damage.
Change rear axle oil, with Limited Slip Diff.
Rotate tires.
Replace air purifier filter.
MILEAGE/ MONTHS
DEALERSHIPNAME/CODE
DATEREPAIR
ORDER #
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 69/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 70/72
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 71/72
PLACE
STAMP
HERE
WARRANTY ADMINISTRATION DEPARTMENTMITSUBISHI MOTORS NORTH AMERICA, INC.6400 KATELLA AVENUECYPRESS, CALIFORNIA 90630-0064
8/13/2019 2005 Lancer Evo Warranty Booklet
http://slidepdf.com/reader/full/2005-lancer-evo-warranty-booklet 72/72