WABCO AUTOMOTIVE SOUTH AFRICA - Home - · PDF filewabco automotive south africa ... 432 410 083 0 airdryer with unloader 9.3 bar port 4/23 scania with heater 9100.00 432 410 001 2

WABCO AUTOMOTIVE SOUTH AFRICA

PRICE LIST FEBRUARY 2014

Pinetown Branch Main Branch Johannesburg Cape Town Branch

Unit 4 Pastel Park 10 Sunrock Close Unit 21 Drill Park,

5A Wareing Road, Pinetown Sunnyrock Ext 2, Germiston Drill Road, Montague Gardens

Telephone +27 (031) 701-4541 Telephone + 27 (0) 11 450-2052 Telephone +27 (021) 552-1231

Telefax +27 (031) 701-4543 Telefax + 27 (0) 11 450-3022/3 Telefax +27 (021) 552-1204

WABCO AUTOMOTIVE SA PRICE LIST - FEBRUARY 2014

INDEX

ABS Components-Truck/Bus 17 Levelling Valves 7

ABS/EBS - Speed Sensors 17 Lift Axle Control Valves 5

Actuator / Hydraulic Actuators 9 Line Filter 10

Adaptor Valves 10 Load Regulating Valve 10

Air Dryers 3 Load Sensing / Levelling Valve Parts 7

Air Processing Units 3 Load Sensing Valves -Air Susp 7

Air Reservoirs 12 Load Sensing Valves -Mech Susp 6

Air Throttle Valves 9 Low Pressure Switches 10

Brake Chambers 11 Manoevering Valve 8

Brake Chambers -Disc Brakes 11 Multi Circuit Protection Valves 4

Cartridges - Desiccant 3 Non-Return Valves 10

Charging Valves 9 Nylon Pipes 14

Clutch Servos 8 Operating Cylinders 9

Compressors 14 Pressure Limiting Valves 9

Compressor spares 14-16 Proportional Solenoid valves (Gearbox) 4

Condensor Drain Valves 4 Quick Release Valves 8

Couplings (Duomatic) 13 Raise / Lower Valve 10

Couplings (F & J) 13 Relay Emergency Valves 6

Couplings (Palm) 13 Ratio Valves 7

Diagnostic Software 17 Relay Valves 6

Diaphragms 12 Rubber Hose 13

Door Control Valve 10 Safety Valves 10

Double Check Valves 10 Shut-Off Cock 10

Double Diaphragm Spring Brakes 11 Silencers 10

Double Diaphragm Spares 12 Slack Adjusters 18

Drain Valves 8 Solenoid Valves 12

EBS Components - Trailers 18 Spiral Binding 17

EBS Components - Truck 18 Spring Boxes 7

EBS Software 18 Spring Brakes 11

ECAS Truck Components 5 Spring Brakes -Disc Brakes 11

Electrical Suzy 13 Spring Brake Spares 11

Exhaust Brake Valves 8 Stop Light Switches 10

Foot Brake Valves 4 Suzy Pipes 13

Fittings Compression 20 TATA Spares 19

Fittings Push In 24 Test Equipment ABS 17

Gearbox / Control / 3/2-way 9 Test Equipment Pneumatic 17

Governor Valves 3 Trailer Control Valves 7

Hand Control Valves 5 Trailer Release Valve (PREV) 10

Unloader Valves 3


PART NUMBER DESCRIPTION

SUGGESTED

RETAIL REPAIR KIT NO

SUGGESTED

RETAIL

UNLOADER VALVES

975 303 473 0 NEW GENERATION WITHOUT AIR DRYER PORT 8.1 BAR 865.94 975 303 001 2 529.81

975 303 474 0 NEW GENERATION FOR USE WITH AIR DRYER 8.1 BAR 865.94 975 303 001 2 529.81

SERVICE KIT For Unloader /473 0 and /474 0 ASA5698 310.52

GOVERNOR VALVES

975 499 017 0 9.2 BAR D2 GOVERNOR 576.00

275508 D2 GOVERNOR 6.5 -7.5 BAR NLA 262723 68.34

AIR DRYERS & APUs

432 410 022 0 AIRDRYER With Unloader 9.5 bar PORT 4/23 NISSAN UD460 4236.00 432 410 001 2 155.66

432 410 002 2 367.25

SERVICE KIT ASA7070 666.07

432 410 083 0 AIRDRYER With Unloader 9.3 bar PORT 4/23 SCANIA WITH HEATER 9100.00 432 410 001 2 155.66

432 410 002 2 367.25

CARTRIDGE (SCANIA) 1 1/4" 13 BAR 432 410 927 2 1245.00


432 410 113 0 AIR DRYER With Unloader 12.5 BAR 3500.00


432 410 117 0 AIR DRYER With Unloader 10 BAR MAN F 2000 2550.00 432 410 002 2 367.25


432 410 200 0 AIR DRYER With Unloader 8.1 BAR + Heater (MAN) 5634.00 432 410 002 2 367.25


432 410 202 0 AIR DRYER With Unloader 8.1 BAR 2900.00 432 410 001 2 155.66


432 410 720 0 AIR DRYER With Unloader 12.5 BAR Without Heater 9636.00

For MAN TGA/TGS/TGL/TGM S/S 432 410 120 0

432 413 003 0 AIR DRYER (ROCKWELL) BACKFLOW 0.7 5684.00 432 413 925 2 195.57

Bypass Valve 432 420 926 2 279.69

Turbo Cut Out valve old number 432 413 928 2 432 413 934 2 479.21

Purge Valve 432 413 929 2 658.58

Regeneration kit 432 413 930 2 NLA


432 415 029 0 DRYER With Unloader 8.3 BAR (E R F) 14528.00 432 415 000 2 1920.38

432 415 055 0 DRYER With Unloader 10 BAR W/O Heater 6956.00

932 400 001 0 DRYER With Unloader 12 BAR (ACTROS) W/O Heater (W/O Port 4/25) NLA See replacement ….024 0

932 400 002 0 DRYER With Unloader 12 BAR (ACTROS) With Heater NLA See replacement ….024 0

932 400 005 0 DRYER With Unloader 12 BAR (ACTROS) W/O Heater (With Port 4/25) NLA See replacement ….024 0

932 400 024 0 DRYER With Unloader 12 Bar With heater Replaces 010/020/050 4312.00 432 410 001 2 155.66

932 400 000 2 1246.91


432 420 220 2 CARTRIDGE (ACTROS) M39 20 BAR 955.00

432 420 002 0 AIR DRYER WITHOUT UNLOADER M12 CONTROL PORT 3663.09 432 410 002 2 367.25


432 421 008 0 AIR DRYER WITHOUT UNLOADER M16 CONTROL PORT 3573.71 432 410 002 2 367.25


432 425 105 0 AIRDRYER FOR VOLVO S/S 432 425 101 0 9020.00 432 425 920 2 1091.29

932 510 956 2 AIRDRYER SCANIA for 932 510 004/5 0 /6 0 12675.30

AIR DRYER CARTRIDGES

432 410 222 7 CARTRIDGE (STD) M39 x 1.5 13 BAR 360.00

432 410 927 2 CARTRIDGE G 1,1/4 13 BAR SCANIA 1245.00

432 420 220 2 CARTRIDGE M39 x 1.5 20 BAR ACTROS 955.00

432 901 223 2 CARTRIDGE With Coalescing Filter M39x1.5 13 BAR 890.00

Stock availability is subject to supplier availability and therefore cannot be guaranteed. Prices exclude VAT and are subject to change without notice

3



SUGGESTED


SUGGESTED

RETAIL

CONDENSOR DRAIN VALVE

432 511 000 0 CONDENSOR DRAIN VALVE 2477.77 432 511 000 2 1268.70

NYLON FILTER 432 511 220 4 432 511 220 4 150.87

MULTI CIRCUIT PROTECTION VALVES

434 700 003 0 2 CIRCUIT PROTECTION VALVE 3768.00 434 700 003 2 2100.00

934 702 100 0 5 PORT 4 X M16 1 X M22 1259.14

934 702 210 0 7 PORT 6 X M16 1 X M22 1733.98 ASA5735 567.28

934 702 221 0 7 PORT 6 X M16 1 X M22 1204.59 ASA5736 567.28

934 702 250 0 5 PORT 4 X M16 1 X M22 960.00 ASA5394 407.55

934 702 260 0 5 PORT 5 X M22 (VOSS) 1204.59 ASA5394 407.55

934 702 300 0 5 PORT 4 X M16 1 X M22 999.00 ASA5391 403.08

934 702 320 0 5 PORT 4 X M16 1 X M22 2056.44

934 705 005 0 PROTECTION VALVE (ACTROS) 6535.00 9347050012 900.00

932 500 501 1 PRESSOR SENSOR FOR 934 705 005 0 replaces 441 043 504 1 3087.37

934 714 003 0 5 PORT 4 X 3/8" 1 X 1/2" 2070.28

934 714 010 0 5 PORT 4 X M16 1 X M22 1395.45

934 714 110 0 5 PORT 4 X M16 1 X M22 1905.55

934 714 145 0 PROTECTION VALVE FOR VOLVO 4372.98

934 714 400 0 PROTECTION VALVE MAN TGA 3479.29

934 714 740 0 7 PORT SUPPLY: 1XM22 DEL M14 3715.13

932 510 958 2 SCANIA PROTECTION VALVE Excluding the PC Board 25558.50

PROPORTIONAL SOLENOID VALVE (GEARBOX, VOITH)

472 260 005 0 PROP Solenoid 10647.25

472 260 011 0 PROP Solenoid 1x M22 Voss 10647.25

472 250 000 0 Proportional Solenoid Valve 5422.21

FOOT BRAKE VALVES W/K 20/01 W/K 21/01

461 315 004 0 MERCEDES 1624 M16 SUP/DEL PORTS M12 GAUGE PORTS 2407.80 461 315 005 2 554.49

SERVICE KIT 461 315 915 2 606.11

461 315 008 0 MERCEDES 1928/2633 M16 SUP/DEL PORTS 0.3 PREDOMINANCE 1980.24 461 315 005 2 554.49

SERVICE KIT 461 315 915 2 606.11

461 315 042 0 VOLVO / SCANIA M16 PORTS 3584.36

461 315 180 0 SCANIA PUSH-IN FITTINGS 6676.72 461 315 907 2 1078.21

SERVICE KIT 461 315 924 2 1217.11

461 315 246 0 FOOT VALVE 9978.00

461 315 264 0 MERCEDES AXOR 2679.92

SERVICE KIT 461 315 927 2 2812.89

461 315 497 0 VOLVO/DAF M16 SUP/DEL PORTS M12 GAUGE PORTS 4586.09 461 315 005 2 554.49

SERVICE KIT 461 315 915 2 606.11

461 319 008 0 MERCEDES 2638 M16 SUP/DEL PORTS M12 SIGNAL PORT 5425.54 461 319 007 2 742.36

SERVICE KIT 461 319 908 2 790.95

461 319 250 0 MERCEDES S.K. RANGE/POWERLINER 2729.55 461 319 004 2 940.81

SERVICE KIT 461 319 905 2 912.59

461 319 270 0 MERCEDES LN2 Econoliner M22 SUP/DEL Ports M16 Signal Port 2729.55 461 319 002 2 580.25

SERVICE KIT 461 319 903 2 580.25

461 319 271 0 MERCEDES 2729.55

461 319 273 0 MERCEDES AXOR 3182.66

461 319 274 0 FOOT VALVE 2791.10

461 324 001 0 MERCEDES 14/18 Repair for Pneumatic Side Only 461 315 005 2 554.49

461 494 502 0 RENAULT Kerax 5940.54

461 499 005 0 DUAL FOOT VALVE MERCEDES 11777.55

470 012 000 0 MERCEDES 2632 C/W SLAVE CYLINDER M16 PORTS 8533.09 461 307 002 2 487.30

See Page 16 for EBS Truck Brake Signal Transmitters (Foot valves)


4



SUGGESTED


SUGGESTED

RETAIL

ECAS SOLENOID VALVES

472 880 001 0 ECAS SOLENOID 6254.04

472 880 030 0 ECAS SOLENOID - TRAILER ECAS and TRUCKS 7088.03

472 900 053 0 WITH 2 HEIGHT SENSORS 5465.00 472 900 009 2 616.67

472 900 060 0 WITHOUT HEIGHT SENSORS 5465.00 472 900 009 2 616.67

472 905 111 0 ECAS SOLENOID - MAN TGA & DAF TRUCKS LIFT AXLES 8575.82 472 905 004 2 2224.61

472 905 114 0 ECAS SOLENOID - TRAILER LIFT AXLES 9262.90

ECAS HEIGHT SENSORS

441 050 012 0 BAYONET WITHOUT LEVER AND TEMPERATURE COMPENSATION 1238.00

441 050 100 0 ECAS LEVELLING VALVE-TRUCK 1570.00



441 050 123 0 BAYONET WITHOUT TEMP COMPENSATION; CROSS LEVER 1405.00

ECAS PRESSURE SENSORS

441 044 102 0 M16 BAYONET WITH O'RING S/S 4410400150 1282.88

ECAS/ELM REMOTE CONTROL UNIT

446 056 116 0 REMOTE CONTROL UNIT 1603.00

LIFT AXLE CONTROL VALVE

463 084 010 0 ELECTRONICALLY CONTROLLED (TRAILER ABS) On request

463 084 020 0 FULLY AUTOMATIC SINGLE CIRCUIT LIFT VALVE 7329.87

463 084 030 0 FULLY AUTOMATIC SINGLE CIRCUIT LIFT AXLE VALVE 4574.38

463 084 041 0 FULLY AUTOMATIC SINGLE CIRCUIT WITH 8mm FITTINGS PI 3936.39

474 100 001 0 ELM (ELECTRONIC LEVELLING MODULE) NLA

HAND CONTROL VALVES

262395M TC2 SHORT HANDLE M14 PORTS 2321.25

961 701 110 0 3 PORT VALVE M14 POARTS (ANTI-CLOCKWISE) 5849.41


961 701 115 0 3 PORT VALVE M14 POARTS (ANTI-CLOCKWISE) 6303.16

961 702 014 0 4 PORT VALVE M14 PORTS 6398.87


961 703 001 0 4 PORT VALVE WITH BUS STOP POSITION M14 PORTS 7137.20 961 703 000 2 1228.09


961 721 000 0 TRAILER BRAKE -IN PRESS -8.5 BAR / OUT = 7.5 BAR 2989.79 961 721 004 2 913.07

961 721 004 0 VALVE WITH HANDLE LOCK (TRAILER BRAKE) 3274.64 961 721 004 2 913.07

961 721 008 0 2 PORT HAND CONTROL (TRAILER BRAKE) 3361.23 961 721 004 2 913.07

961 721 040 0 SELF RETURN T.C.2 (TRAILER BRAKE) 3868.86 961 721 004 2 913.07

961 721 045 0 2 PORT with DUST BOOT 2009.29

961 722 151 0 2 PORT SIDE M14 (MB) 3733.49

961 722 230 0 2 PORT SLIDE (LHD BRACKET) (MB) 3666.59 961 722 002 2 1336.30

961 722 232 0 3 PORT HAND CONTROL & SLIDE TYPE CONNECT (VOSS) M14 3568.60 961 722 003 2 939.01


961 722 252 0 H/CTRL (LHD BRACKET) 3 PORT M14 2719.52 961 722 003 2 939.01


961 722 258 0 H/CTRL (CENTRE BRACKET) 3 PORT M14 2413.76 961 722 003 2 939.01


961 722 264 0 HAND CONTROL 4 PORT M14 3582.27 961 722 004 2 2404.45


961 722 272 0 HAND CONTROL INT. (RHD) 2719.52 961 722 003 2 939.01


961 722 284 0 4 PORT (RHD BRACKET) (MB) 2830.27 961 722 003 2 939.01


961 722 288 0 3 PORT (RHD BRACKET) M14 PORTS (MB) 4512.02 961 722 003 2 939.01


961 722 314 0 3 PORT SIDE M14 (SCANIA) 4349.22

961 723 017 0 PARKING HAND CONTROL 1916.94 961 723 000 2 1916.51

961 723 019 0 2 PORT (CENTRE BRACKET) M16 PORTS (MAN) 2278.80 961 723 000 2 1916.51

961 723 100 0 3 PORT (CENTRE BRACKET) M16 PORSTS (MAN) 3384.02 961 723 000 2 1916.51

961 723 104 0 H/CTRL POWER LINER 3 PORT M16 VOSS (SIDE) 2823.18 961 723 000 2 1916.51


5



SUGGESTED


SUGGESTED

RETAIL

HAND CONTROL VALVES Continued……………

961 723 118 0 3 PORT (CENTRE BRACKET) M14 VOSS PORTS (MAN) 1794.14

961 723 124 0 3 PORT (CENTRE BRACKET) M16 PORTS (MB) 2639.00

961 723 125 0 H/CTRL (ACTROS) 3 PORT M16 (SIDE) VOSS 3622.40

961 723 201 0 3 PORTS (BOTTOM) M16 CENTRE BRACKET 3902.17 961 723 000 2 1916.51

961 723 203 0 3 PORT (CENTRE BRACKET) M16 PORTS 2748.51 961 723 000 2 1916.51

961 723 213 0 3 PORTS (BOTTOM) M16 CENTRE BRACKET 3571.39

961 723 405 0 H/CTRL 2 PORT M16 (BOTTOM) 2443.88 961 723 001 2 1238.32

961 723 426 0 H/CTRL MAN TGA WITH ELECTRICAL PLUG 4707.26

RELAY VALVES

280375 R6 VALVE 615.00 263945 140.92

472 195 031 0 ABS SOLENOID RELAY VALVE (TRAILER) 2381.14

480 202 004 0 EBS RELAY VALVE (ACTROS) 7495.66

973 001 010 0 M22 PORTS SQUARE RELAY VALVE 734.64 973 001 000 2 403.39

ASA5198 72.81

973 001 020 0 M16 PORTS SQUARE RELAY VALVE 734.64 973 001 000 2 403.39

ASA5198 72.81

973 001 220 0 M16 SQUARE RELAY VALVE 1682.86 973 001 002 2 NLA

973 003 007 0 M22 SQUARE RELAY (MAN) 2865.64

973 006 001 0 PLASTIC WITHOUT SILENCER M22/M22/M16 VOSS 1152.50

973 006 003 0 PLASTIC WITH SILENCER M22/M22/M16 VOSS 865.10

973 011 000 0 PORT 1 & 2 M22, PORT 4 M16, NO SILENCER 809.44 ASA7168 86.59

973 011 001 0 M22 PORTS (MAN / SCANIA) PORT 1&2 M22 VOSS/PORT 4 M16 1134.57 ASA7168 86.59

973 011 022 0 3/8" PORTS WITH FLANGE FREIGHTLINER 1239.28 ASA7168 86.59

973 011 050 0 M22 SUPPLY PORTS / DEL PORTS M16 807.64

973 011 200 0 MAN / SCANIA 1122.52 ASA7168 86.59

973 011 206 0 RENAULT PORT 1 & 2 M22, PORT 4 M16, 1919.51

973 011 300 0 ACTROS 1724.85

480 202 005 0 RELAY VALVE(ACTROS) - 8X4 6295.57

RELAY EMERGENCY VALVES

281672 RE6 VALVE 760.00 266784 252.72

471 005 020 0 RELAY EMERGENCY VALVE On request

971 002 150 0 RELAY EMERGENCY VALVE 3342.05 971 002 003 2 1826.47

971 002 300 0 RELAY EMERGENCY VALVE 3546.27 971 002 008 2 1607.65

971 002 900 0 PARK RELEASE EMERGENCY VALVE (PREV VALVE) 2583.30

LOADSENSING VALVES (MECHANICAL SUSPENSION)

475 702 022 0 LOAD SENSING VALVE / MECHANICALLY CONTROLLED 6793.82

475 710 008 0 M22 PORTS PORT 4 M16 On request 475 710 001 2 803.39


475 710 012 0 M22 PORTS VOSS PORT 4 M16 VOSS (MAN L2000 / M2000 / M2000L) 4496.18

475 710 016 0 M22 VOSS PORTS PORT 4 M16 VOSS (MAN) 2872.11 475 710 001 2 803.39


475 710 020 0 DYNAMIC M16 PORTS 3314.33 475 710 001 2 803.39


475 710 024 0 RELAY LOAD SENSING IVECO PORT 1 M22, 2 & 4 M16 7903.33 475 710 001 2 803.39


475 710 036 0 RELAY LOAD SENSING DYNAMIC 22 DIA DEL. PORTS 2227.95 475 710 001 2 803.39


475 710 128 0 PORT 1 M22. PORT 2 M16 (VOLVO FH12 / FH16) 5057.44

475 710 136 0 M16 VOSS PORTS PORT 1 M22 VOSS (MERCEDES) 3777.79 475 710 001 2 803.39


475 713 501 0 PORT 1/4 M22. PORT 2 M16 Static Valve 2404.76

475 720 003 0 NEW GENERATION MINI LSV DAF 4442.61


475 720 005 0 NEW GENERATION MINI LSV 2783.50


6



SUGGESTED


SUGGESTED

RETAIL

LOAD SENSING VALVE (AIR SUSPENSION)

475 711 024 0 CONTROL PRESSURE 0.6 TO 4.3 BAR 3764.24 475 711 000 2 1508.65

475 711 096 0 CONTROL PRESSURE 0.45 TO 6.1 BAR 4851.01 475 711 000 2 1508.65

475 711 115 0 CONTROL PRESSURE 0.6 TO 4.3 BAR 4359.85

475 711 118 0 CONTROL PRESSURE 0.5 TO 3 BAR 5396.64 475 711 000 2 1508.65

475 714 510 0 CONTROL PRESSURE 0.4 TO 3.6 BAR 2743.00

475 721 000 0 M16 PORTS PORT 22 M22 (DAF SCANIA) 0.5 TO 4.7BAR 5263.81


475 721 008 0 NEW GENERATION MINI LSV AXOR 9249.81

475 721 009 0 NEW GENERATION MINI LSV AXOR 4414.98

LOAD SENSING / LEVELLING VALVE SPARES

433 300 381 4 LINK CONNECTION (RUBBER STRAIGHT) 60.30

433 300 383 4 LINK CONNECTION (RUBBER L SHAPE) 65.58

433 300 385 4 LINK CONNECTION (RUBBER L SHAPE) LEVELLING 189.12

433 401 380 4 RUBBER LINK (464 002 … 0) LEVELLING VALVE 168.45

464 002 730 2 METAL ARM (464 002 … 0) LEVELLING VALVE 320.97

475 701 712 2 LOAD SENSING ARM WITH RUBBER LINK 201.11

475 710 130 4 ROLLER (475 710 … 0) 12.99

475 710 770 4 PLASTIC PLUNGER (475 710 … 0) 43.52

A5349LSU LSU COILED ARM 382.84

A5426 BRACKET (SPRINGBOX MOUNTING/SINGLE AXLE) 99.15

A5427 BRACKET (SPRINGBOX BOUNTING/TANDEM AXLE) 55.82

ASA5080 LINKAGE KIT LSV TANDEM AXLE 670.01

ASA5081 LINKAGE KIT LSV SINGLE AXLE 347.00

433 401 003 0 LINKAGE KIT Levelling Valve 228.24

441 050 718 2 Flat Arm for ECAS Distance Sensor / Levelling Valve 463.38

475 713 710 2 Arm and Cable for 475 713 … 0 Mechanical LSV 1018.45

A6356 DATA PLATE -MECHANICAL/AIR SUSPENSION VALVE 54.32

SPRING BOXES

433 302 002 0 (260MM LONG) 20-35N With Rubber Connector 419.90

433 302 008 0 (160MM LONG) 40-100N With Knuckle Joint 921.25

433 302 014 0 (220MM LONG) 26-47N WithOUT Rubber Connector 512.88

433 302 026 0 (220MM LONG) 449-145N With Rubber Connector 569.60

RATIO LOAD VALVES

473 300 001 0 3.3:1 RATIO VALVE 4391.59

473 300 004 0 1.5:1 RATIO (EXTRA CONTROL PORT 4) 4879.35

473 301 000 0 2:1 RATIO 3350.49

473 301 001 0 1.5 :1 RATIO 2931.32

473 301 002 0 1.35 :1 RATIO 3542.49

TRAILER CONTROL VALVES

480 204 002 0 ACTROS/ NISSAN/ DAF E.B.S. (REPLACES 001 0 VARIANT) 7633.98

973 002 000 0 WITH SPRING BRAKE PORTS (M22) NO DUMP 5019.42 ASA5741 340.37

973 002 430 0 (M16) PORT NO DUMP NO PREDOMINANCE 3139.42 ASA5741 340.37

973 002 521 0 WITH DUMP VALVE (M16) PREDOMINANCE .2 BAR (Adjustable) 2389.73 ASA5741 340.37

973 009 001 0 WITH DUMP VALVE (M22 VOSS) POWERLINER 2838.26 973 009 000 2 1077.81

973 009 006 0 WITH DUMP VALVE (M22 VOSS) MAN 2838.26 973 009 000 2 1077.81

973 009 014 0 WITH DUMP VALVE (M16) PREDOMINANCE 0,4 BAR (Adjustable) 3970.77 973 009 000 2 1077.81

973 009 015 0 WITH DUMP VALVE (M16) VOLVO 0.1 PREDOMINANCE 3970.77 973 009 000 2 1077.81

973 009 010 0 WITH DUMP VALVE (M16) 0.2 PREDOMINANCE 4944.57

LEVELLING VALVES

464 002 330 0 2 STAGE (INT) WITH ARM (VOLVO/IVECO) 1736.52 464 002 008 2 435.75

464 002 440 0 2 STAGE -WITH ARM (M.A.N.) 2176.60 464 002 008 2 435.75

464 006 002 0 2 STAGE -WITH ARM (M.A.N./B.P.W.) 1683.79 464 006 000 2 861.39

464 006 100 0 2 STAGE -WITH ARM (DAF/TRAILER) 2138.21

464 007 001 0 CAB SUSPENSION (PUSH-IN) 1855.66

464 007 010 0 CAB SUSPENSION (M10 X 1) 2053.40


7



SUGGESTED


SUGGESTED

RETAIL

CLUTCH SERVOS

970 051 111 0 M.A.N. (STROKE 85MM / DIA 80.5MM) 4420.13 970 051 905 2 NLA

970 051 114 0 HINO/FIAT (STROKE 67MM / DIA 80.5MM) 4743.78 970 051 904 2 2360.65

SERVICE KIT 897 754 882 4 144.27

970 051 126 0 NISSAN/HINO (STROKE 85MM / DIA 80.5MM) 3489.25 970 051 904 2 2360.65

SERVICE KIT 897 754 882 4 144.27

970 051 127 0 CLUTCH SERVO SCANIA (STROKE 58.5MM / DIA 108MM) 6810.61 970 051 906 2 2360.65

SERVICE KIT 897 754 882 4 144.27

970 051 128 0 CLUTCH SERVO MERC. (STROKE 58.5MM / DIA 108MM) 10441.48 970 051 906 2 2360.65

SERVICE KIT 897 754 882 4 144.27

970 051 131 0 MERCEDES (STROKE 72MM / DIA 90MM) 7134.00 970 051 903 2 847.85

M B HOUSING … 131 0 SERVO 970 051 527 2 950.26

GUIDE …131 0 SERVO 970 051 371 4 NLA

SERVICE KIT 897 754 320 4 98.44

970 051 151 0 MERCEDES (STROKE 72MM / DIA 90MM) 10851.07 970 051 917 2 5098.51

970 051 157 0 CLUTCH SERVO MAN (STROKE 85MM / DIA 108MM) 10495.14 970 051 911 2 NLA

970 051 159 0 MERCEDES (NEW GENERATION) (STROKE 85MM / DIA 108MM) 8707.62 970 051 916 2 2375.86

970 051 164 0 MERCEDES LN2 (STROKE 85MM / DIA 108MM) 4961.62

SERVICE KIT 897 754 882 4 144.27

970 051 406 0 MAN F2000 (STROKE 85MM / DIA 75MM) 4565.35 970 051 952 2 5142.62

970 051 412 0 CLUTCH SERVO FOR MAN TGA –MINERAL OIL 8413.58 970 051 971 2 3896.36

970 051 414 0 MAN F2000 (STROKE 85MM / DIA 108MM) 3884.73 970 051 961 2 2273.95

SERVICE KIT 897 754 882 4 144.27

970 051 424 0 HINO 700 (STROKE 85MM / DIA108MM) 5247.58 970 051 961 2 2273.95

SERVICE KIT 897 754 882 4 144.27

970 051 431 0 ACTROS (STROKE 85MM / DIA 102MM) Kit Includes Main Seal 5564.26 970 051 974 2 3226.11

SERVICE KIT 897 754 882 4 144.27

970 051 432 0 CLUTCH SERVO MAN TGM (STROKE 85MM/DIA 80MM) MINERAL OIL 10422.95

970 051 435 0 MAN (STROKE 85MM / DIA 75MM) 7955.02 970 051 970 2 2552.30

SERVICE KIT 897 754 882 4 144.27

970 051 438 0 CLUTCH SERVO FOR RENAULT (INCL. 3/2 DIR. CONTR. VALVE) 10962.12 970 051 984 2 3668.74

970 051 439 0 CLUTCH SERVO FOR MAN (STROKE 25 / DIA 108MM) 9458.02 970 051 984 2 3668.74

970 051 441 0 ACTROS/AXOR - MINERAL OIL Kit Excludes main Seal 8234.00 970 051 987 2 840.43

970 150 001 0 ACTROS MP11 (Alternative for 9701500020) 16150.00 970 150 000 2 4341.04

NOTE: SPECIAL INSTALLATION INSTRUCTIONS

970 051 187 0 CLUTCH SERVO 5534.00

DRAIN VALVES

SF1280 MANUAL DRAIN VALVE 1/4"NPTM 52.25

934 300 003 0 MANUAL TILT TYPE M22 67.68

934 300 006 0 MANUAL DRAIN VALVE 1/2" NPT 125.33

934 301 000 0 AUTO DRAIN VALVE M22 1096.93

934 301 003 0 AUTO DRAIN VALVE M22 1096.94

QUICK RELEASE VALVES

973 500 000 0 M22 PORTS 258.00

973 500 014 0 1/2" X 3/8" X 3/8" PORTS 270.00

973 500 031 0 POWER LINER M22 (VOSS) (4 PORT) 485.18

973 500 051 0 WITH ANTI-COMPOUND, DOUBLE CHECK VALVE FOR EBS TRAIL. 880.52

MANOEUVERING VALVES

ASA1689 PUSH AND HOLD TYPE WITH FITTINGS 926.75

EXHAUST BRAKE VALVES

463 013 111 0 SHORT STEM -2 X M12 PORTS WITHOUT LOCK NUT 460.20 ASA5705 69.50

463 013 112 0 SHORT STEM -2 X M12 PORTS WITHOUT LOCK NUT 460.20 ASA5705 69.50

463 013 114 0 LONG STEM -2 X M12 PORTS WITHOUT LOCKNUT 460.20 ASA5705 69.50

463 013 116 0 SHORT STEM -2 X M12 PORTS WITH LOCKNUT 550.00 ASA5705 69.50

463 013 130 0 SHORT STEM -3 X M16 PORTS (VOSS) WITHOUT LOCKNUT 696.30

463 013 200 0 SHORT STEM -3 X M16 PORTS (VOSS) WITHOUT LOCKNUT 801.80

463 013 210 0 SHORT STEM -2 X M16 -1 X M12 PORTS (VOSS) WITHOUT LOCKNUT 801.80

891 500 464 4 LOCK NUT M26 14.00 15.72


8



SUGGESTED


SUGGESTED

RETAIL

OPERATING CYLINDERS

421 411 070 0 CYLINDER - DIA 35MM, STROKE 85MM 1911.95



421 429 003 0 A.D.E. CYLINDER 407/400 / DIA : 28MM -STROKE 48MM 1433.34

AIR THROTTLE

361 064 050 0 AIR THROTTLE VALVE 8550.00 361 050 000 2 270.20

DIAPHRAGM FOR (423 020 016 0) 897 121 030 4 1019.76

ACTUATOR / SERVO UNITS

425 307 012 0 ACTUATOR 100MM X 80MM STROKE 8555.18 425 307 000 2 1045.01

AGA199 MADE UP 425 307 012 0 + CLEVIS 8555.18

921 399 025 0 AIR/HYDRAULIC ACTUATOR 6428.81

974 010 006 0 SERVO MASTER SUPERCEDED TO 974 010 008 0 NLA

974 010 008 0 SERVO MASTER MAN TGL (WITH MASTER CYLINDER) on request

GEARBOX VALVES / DIRECTIONAL CONTROL VALVES

463 022 020 0 VALVE M10 PORTS 1424.25

463 036 001 0 DIFLOCK M10 PORTS WITH KNOB WITHOUT LOCKNUT 601.63

463 036 010 0 M16 VOSS PORTS WITHOUT KNOB WITHOUT LOCKNUT 662.84

463 036 016 0 DIFF LOCK SWITCH (M28 MOUNTING) 1036.05

463 037 001 0 M10 4/2 CONTROL VALVE WITHOUT HANDLE & LOCKNUT 1152.61

463 039 006 0 DAIMLER ZF BOX 3398.00 463 039 000 2 NLA

463 063 002 0 5/2 RANGE CHANGE (DAIMLER) Port 22: RHS 4384.48 463 063 000 2 1461.11

463 063 003 0 5/2 RANGE CHANGE (MAN) Port 22: LHS 4735.24

563 020 000 0 3/2 CONTROL VALVE (MAN) -M10 1842.83

571 040 000 0 3/2 CONTROL VALVE 3 X M14 -1 X M10 1279.39

891 500 520 4 M28 LOCKNUT FOR 463 037 001 0 130.72

899 851 810 4 HANDLE FOR 463 037 001 0 246.43

A5821 WASHER FOR M28 LOCKNUT 42.04

ASA5910 MADE UP 463 036 001 0 & WASHER & NUT 786.45

CHARGING VALVES

434 100 023 0 5.5 BAR WITH BACKFLOW (M22) 524.22 ASA5699 83.00

434 100 024 0 6.0 BAR WITH BACKFLOW 580.25 ASA5699 83.00

434 100 122 0 4.5 BAR WITHOUT BACKFLOW (M22) 522.23 ASA5699 83.00



434 100 220 0 4.5 BAR WITH LIMITED BACKFLOW (M22) 485.30 ASA5700 NLA

434 100 222 0 6.2 BAR WITH LTD BACK FLOW 874.82 ASA5700 NLA




PRESSURE LIMITING VALVES

475 009 008 0 SET AT 0.7 BAR (MAN) 1466.11

475 009 026 0 SET AT 3.0 BAR 2068.89

475 010 010 0 PRESSURE LIMITING VALVE (3.5 TO 6 BAR) 1882.12

475 010 300 0 SET AT 8.5 BAR (MAN) 841.89

475 010 301 0 SET AT 10.0 BAR (MAN) 841.89

475 010 333 0 PRESSURE LIMITING VALVE MAN TGA. 1202.70

475 010 400 0 SET AT 8 BAR (DAF) 1341.96 475 010 002 2 873.51

475 015 001 0 SET AT 7.4 BAR (MAN- MERCEDES) 1048.67 475 015 001 2 389.48

475 015 004 0 PRESSURE LIMITING VALVE (SET AT 3.5 BAR) (MAN- Merc) 719.51 475 015 001 2 389.48

475 015 009 0 PRESSURE LIMITING VALVE (SET AT 5.3 BAR) (Renault) 943.17 475 015 001 2 389.48

475 015 061 0 PRESSURE LIMITING VALVE (SEE 421 355 931 2 kit) ZF Gearbox see kit 421 355 931 2 3758.52


9



SUGGESTED


SUGGESTED

RETAIL

DOUBLE CHECK VALVES

434 208 024 0 VALVE WITH 3/8"NPT PORTS 486.75

434 208 029 0 VALVE WITH INTEGRAL BRACKET (M22) PORTS 332.19

NON-RETURN VALVES

434 014 000 0 M22 PORTS 185.64

SAFETY VALVES

434 612 004 0 ACTROS M22 13 BAR 367.91

SHUT OFF COCKS

452 002 132 0 M22 WITH EXHAUST 180º 400.90

LOAD REGULATING VALVE

475 800 301 0 OPERATING PRESSURE 7.35 BAR (M22) 6510.00 475 800 004 2 2458.64

LOW PRESSURE SWITCH

441 014 004 0 L.P. SWITCH 5.5+0.6 Bar (M12) Normally Closed 434.69






AGA987 L.P. SWITCH 4.5Bar 1/4" NPT Normally Closed 385.80

ADAPTOR VALVES

975 001 000 0 0.6 TO 0.8 BAR 1395.14

975 002 001 0 1 TO 1 RATIO AT 5.8 BAR 2232.89

975 002 017 0 1 TO 1 RATIO AT 4 BAR 2010.72

DOOR CONTROL VALVE

472 017 480 0 24V M12 PORTS 6021.54 472 017 000 2 2126.80

SILENCERS

432 407 060 0 M22 -13 BAR SCREW ON 148.58

432 407 070 0 SNAP-ON -11 BAR 191.59

RAISE / LOWER VALVE

463 032 020 0 SUPPLY -M16. DEL -M12 2569.82

TRAILER RELEASE VALVE

963 001 051 0 PARK / SHUNT VALVE 3275.49

971 002 900 0 PREV (Park Relay Emergency Valve) EBS Trailer systems 2583.30

STOP LIGHT SWITCH

262625 STOPLIGHT SWITCH 1/4"NPT 904.22

441 014 001 0 STOPLIGHT SWITCH 2 BAR (M12) 413.73

441 014 019 0 STOPLIGHT SWITCH 0.15 BAR (M12) 755.88

441 014 021 0 STOPLIGHT SWITCH 0.5 BAR (M12) 353.98

LINE FILTER

432 500 020 0 LINE FILTER M22 X M22 198.00


10



SUGGESTED


SUGGESTED

RETAIL

BRAKE CHAMBERS

AGA109 TYPE 20 658.23

AGA339 TYPE 12 898.49

AGA448 TYPE 24 LONG STROKE REPLACES AGA351 628.95

AGA449 TYPE 30 LONG STROKE REPLACES AGA354 685.92

423 105 111 0 T20 WITH STUDS 1505.25

423 106 292 0 T24 WITH STUDS 1761.05

423 107 900 0 T30 (M16 PORTS) 1201.07

423 109 001 0 T27 WITH STUDS 2013.85

423 205 101 0 T20 WITHOUT STUDS 1929.12

423 206 700 0 T24 WITHOUT STUDS On Request low stock

423 206 701 0 T24 WITHOUT STUDS On Request low stock

BRAKE CHAMBER (DISC BRAKE)

423 104 710 0 T16 1635.11

SPRING BRAKES / TRI-STOP

925 320 502 0 TRISTOP TYPE 20-30 WELDED PUSH ROD 6899.42 925 320 002 2 406.08





925 424 100 0 TRI-STOP TYPE 16-24 WELDED PUSH ROD 3393.86

925 424 101 0 TRISTOP TYPE 16-24 WELDED PUSH ROD 3700.50

425 451 052 0 TRISTOP TYPE 24-24 WEDGE TYPE RIGHT - NISSAN 8734.82

425 451 053 0 TRISTOP TYPE 24-24 WEDGE TYPE LEFT - NISSAN 8734.82

925 490 902 0 TRISTOP TYPE 20-24 WELD PUSH ROD REPLACES 925 420 902 0 6054.99 925 320 001 2 398.70

925 490 041 0 UNIVERSAL TYPE 16-24 NO Clevis, nuts and washers, see AGA432 4879.88



925 492 102 0 UNIVERSAL TRISTOP TYPE 30-30 4353.26

AGA431 UNVERSAL (9254909250) 20-24 with Clevis, nuts and washers 5116.77

AGA430 UNVERSAL (9254911410) 24-24 with Clevis, nuts and washers 4900.78

AGA432 UNIVERSAL (9254940410) 16-24 with Clevis, nuts and washers 4879.88

SPRING BRAKES (DISC BRAKES)

925 424 800 0 TRISTOP TYPE 16-16 (M22 VOSS) LHS 3878.64

925 424 801 0 TRISTOP TYPE 16-16 (M22 VOSS) RHS 3878.64

925 426 200 0 TRISTOP TYPE 14-16 (M22 VOSS ) LHS 3676.00

925 426 201 0 TRISTOP TYPE 14-16 (M22 VOSS ) RHS 3676.00

925 480 004 0 TRISTOP TYPE 20-24 (M22 VOSS) 4861.23



925 488 012 0 TRISTOP TYPE 14-24 (M22 VOSS) RHS On request



925 488 021 0 TRISTOP TYPE 14/24 (M22 VOSS) 4797.34

SPRING BRAKES/DOUBLE DIAPHRAGM

AGA262 DOUBLE DIAPHRAGM TYPE 12/12 On Request

AGA445 DOUBLE DIAPHRAGM TYPE 24/30 LS REPLACES AGA349 1426.00

AGA447 DOUBLE DIAPHRAGM TYPE 30/30 L S REPLACES AGA350 1688.59

SPRINGBRAKE SPARES

895 801 513 2 M16 X 14MM PIN CLEVIS 122.49

897 750 980 4 DUST BOOT (1 HOLE) 43.44

897 751 010 4 DUST BOOT (1 X LARGE HOLE) 43.44

897 753 261 4 DUST BOOT (2 HOLE) 63.58

925 321 010 2 TYPE 16/24 REAR HOUSING (STEEL) 731.96



A5803 DUST BOOT MAXI BOOSTER T24 196.46

ASA6194 KIT MAXI BOOSTER T24 360.97


11



SUGGESTED


SUGGESTED

RETAIL

DOUBLE DIAPHRAGM SPARES

A5948 CENTRE SEAL KIT 28.24

ASA1779 T24 PUSH ROD 89.56

ASA1780 T30 PUSH ROD 107.96

ASA5267 5/8" CLEVIS X 1/2" PIN 139.24

ASA6294 CLEVIS M16 X 1.5 X 1/2" PIN 121.92

895 801 513 2 CLEVIS M16 X 1.5 X 1/2" PIN 122.49

ASA6868 LONG CLEVIS 5/8" Thread X 1/2" PIN 142.69

DIAPHRAGMS

897 121 030 4 TYPE 3 1019.76

234433M TYPE 9 56.94

234226M TYPE 12 61.49

897 121 610 4 WABCO TYPE 14 263.29

A6447 TYPE 16 98.97

897 120 510 4 WABCO TYPE 16 181.28

A6448 TYPE 20 98.97

897 120 520 4 WABCO TYPE 20 184.18

A2400 TYPE 24 57.09

897 120 530 4 WABCO TYPE 24 211.79

897 120 536 4 TYPE 24 DEEP DISH 386.97

897 121 925 4 TYPE 27 558.24

A3000 TYPE 30 62.80

897 120 540 4 WABCO TYPE 30 252.71

897 120 546 4 WABCO TYPE 30 LONG STROKE 266.73

234362M TYPE 36 NLA

SOLENOID VALVES

472 070 639 0 (24V M16 PORTS) NORMALLY CLOSED 1111.04

472 090 202 0 (24V 1/4" PORTS) NORMALLY CLOSED 1651.65

472 102 040 0 24V NORMALLY OPEN 2906.77

472 132 198 0 (24V M12 PORTS) NORMALLY CLOSED 1780.84

472 170 600 0 24V NORMALLY CLOSED M12 (Kostal) 1137.57

472 172 600 0 24V NORMALLY CLOSED M12 (Kostal) 2117.29

472 172 620 0 24V NORMALLY CLOSED M12 2070.13

472 172 626 0 24V NORMALLY CLOSED 963.61

472 172 686 0 24V NORMALLY CLOSED DAF 930.05

472 173 700 0 24V NORMALLY OPEN 2607.49

472 174 504 0 24V NORMALLY CLOSED M12 4368.42

472 176 316 0 24V NORMALLY OPEN M16 ACTROS/DAF 1783.44

AIR RESERVOIRS

8" DIA (203MM) Length

AGA179 5 LITRE RESERVOIR 666.69 195MM

051010004M 10 LITRE RESERVOIR 781.63 355MM



A6104 TANK STRAP 8" DIA (SINGLE) 105.78

11" DIA (276MM)





1675062M TANK STRAPS 11" DIA. (PAIR) 207.37

390mm DIA

A6741 FATBOY 90 LITRE RESERVOIR 2726.98

A6742 FATBOY TANK STRAPS (PAIR) 621.55


12



SUGGESTED


SUGGESTED

RETAIL

F & J COUPLINGS AND SPARE PARTS

Standard Special Project

0520010022 1/2" Female std 65.00 0520010022D 102.00

A6722 M22 x 1.5 Female with striker plug assembled Trailer A6722D 174.00

APSA1519 1/2" Female with striker plug assembled Trailer 75.00 APSA1519D 174.00

0520010062 1/2" Female F&J with short stem shut off valve Truck 120.75 0520010062D 195.80

0520003005 M16 x 1.5 Female F&J with short stem shut off valve Truck 0520003005D 231.43

ASA531/2 1/2" Female F&J with short stem shut off valve Truck 180.00 ASA531/2D 242.97

0520010032 1/2" Short stem Shut off valve only 41.10 0520010032D 75.00

0520000014 1/2" Male Coupling std Trailer 17.10 0520000014D 58.00

0520000024 M22 x 1.5 Male Coupling std Trailer 0520000024D 54.00

0520030052 1/2" Male F&J with long stem shut off valve Truck 150.00 0520030052D 166.16

A6704 M22 x 1.5 Male F&J with long stem shut off valve A6704D 149.00

0520001005 M16 x 1.5 Male F&J with long stem shut off valve Truck 105.00

0520030062 1/2" Male F&J with long stem shut off valve Truck 334.95 0520030062D 494.83

0520030012 1/2" long stem Shut off valve only 43.50 0520030012D 76.92

AP11168 1/2" STRIKER PLUG / Operating Plug 16.50 AP11168D 52.44

A5776 M22 x 1.5 STRIKER PLUG NLA

0520030022 Dust cover (Female dummy) for male couplings with Chain and bracket 145.95

0520030142 Dust Flap Nylon for Female Couplings 26.40

1178075 Dust Plug male for female couplings with chain and bracket 122.47

A1121 Service Tag 11.41

A1122 Emergency Tag 11.41

0520030152 Plastic Mounting Bracket 16.50

PALM COUPLINGS

897 550 020 4 REPLACEMENT SEAL (PALM COUPLING) 20.00

952 200 021 0 EMERGENCY PALM (TRAILER) COUPLING 222.43

952 200 022 0 SERVICE PALM (TRAILER) COUPLING 222.43

952 200 221 0 EMERGENCY PALM (TRUCK) COUPLING 356.86

952 200 222 0 SERVICE PALM (TRUCK) COUPLING 356.86

DUOMATIC COUPLINGS

452 802 009 0 M16 X 1.5 TRUCK 2522.80

452 804 012 0 M16 X 1.5 TRAILER 539.64

ELECTRICAL SUZY

AGA347 7 PIN COIL WITH SOCKETS 1761.36

AGA348 15 PIN COIL WITH SOCKETS 2886.49

A6698 7 PIN FEMALE SOCKET EASY CONNECTION 439.81

A6699 7 PIN MALE PLUG EASY CONNECTION 439.81

A6701 15 PIN MALE PLUG EASY CONNECTION 851.73

A6700 15 PIN FEMALE SOCKET EASY CONNECTION 713.26

RUBBER HOSE

A3626 1/2" S.A.E. SPEC. HOSE PER METRE (SAE J1402) 68.44

SUZY PIPES

ASA5477 RED SUZI WITH SPRINGS & FITTINGS 306.86

ASA5478 YELLOW SUZI WITH SPRINGS & FITTINGS 306.86


13



SUGGESTED


SUGGESTED

RETAIL

NYLON PIPES Prices are indicated Per/ Metre

828 251 908 6 06 BLACK 13.77

A6038 06 RED 13.77

A6041 06 YELLOW 13.77

A6119 06 BLUE 13.77

A6245 06 GREEN 13.77

828 251 907 6 08 BLACK 18.16

A6914 08 RED On request

A6244 08 YELLOW 18.16

A6241 08 BLUE 18.16

A5912 08 GREEN 18.16

A6599 09 BLACK On request

828 251 906 6 010 BLACK 24.06

A3005/N/10R 010 RED 25.51

A3005/N/10SB 010 BLUE On request

A3005/N/10SY 010 YELLOW 25.51

A5405 010 GREEN On request

A5606 011 BLACK (PUSH ON) 44.32

A5632 012 RED 39.55

A5633 012 GREEN 39.55

A5634 012 YELLOW 39.55

A5635 012 BLUE 39.55

A5782 012 BLACK 39.55

A5607 013 BLACK (PUSH ON) 51.71

828 251 904 6 015 BLACK 55.58

COMPRESSORS

411 003 011 0 SINGLE 150CC COMPRESSOR (SELF LUBE) 14500.00

411 034 501 0 SINGLE 229CC COMPRESSOR (M/BENZ OM 355) 8050.00

411 141 000 0 SINGLE 75MM BORE COMPRESSOR (MONO BLOCK) 12640.69

411 142 711 0 SINGLE 90MM BORE COMPRESSOR (M/BENZ) 9190.00

411 145 507 0 SINGLE 75MM BORE (MAN) 10350.00

411 151 008 0 SINGLE 85MM WATER COOLED (M/BENZ) On request

411 154 004 0 SINGLE 85MM BORE (ACTROS/ATEGO) REPLACES 411 154 003 0 10600.00

411 553 003 0 COMPRESSOR FOR ATEGO BUS S/S 411 553 001 0 31037.28

412 100 806 2 MAN HEAD ONLY (F2000) NO GASKET S/S 412 100 805 2 2732.09

412 352 003 0 SINGLE 85MM BORE (MAN) 9200.00

412 352 027 0 AXOR COMPRESSOR ESS 9785.00

Mounting Flange gasket only from Merc A457 131 018 0

412 704 008 0 TWIN 85mm Bore (VOLVO) with ESS 5 Hole Mount (20701801) 17200.00

412 704 014 0 COMPRESSOR FOR VOLVO FM 9 with ESS 5 Hole Mount (20842990) 28040.44

911 155 521 0 COMPRESSOR CUMMIN'S ISC ENGINE 13535.65

911 504 506 0 COMPRESSOR FOR DAF 95X S/S 911 504 504 0 ESS 15780.69

911 505 150 0 TWIN COMPRESSOR VOLVO FL7 3 Hole Mount centre 16814.26

911 506 505 0 TWIN 75MM BORE (IVECO) 22698.76

912 510 103 0 TWIN 85mm Bore (AXOR) 29600.00

913 510 104 0 TWIN 85mm Bore (AXOR) 29600.00

912 512 008 0 VOLVO B13 19242.19

412 704 018 0 TWIN 85mm Bore (VOLVO) ESS 3 Hole Mount off centre (21172036) 31020.00

M101170 COMPRESSOR FOR MAN CLA 8120.00

COMPRESSOR SPARES

411 003 000 0 COMPRESSOR SUPERCEDED TO 411 003 011 0 NLA

ASA5272 GASKET KIT INCLUDING OIL SEAL 225.60

ASA5273 RING SET (75MM BORE) 349.83

411 003 340 4 CON ROD BEARING 463.39

411 141 623 2 PISTON COMPLETE 1514.96

411 003 011 0 SELF LUBE 150CC COMPRESSOR S/S 411 003 000 0

ASA5272 GASKET KIT (INCL. OIL SEAL) 225.60

ASA5273 RINGS (75MM BORE) 349.83

ASA6282 HEAD KIT 1066.19

411 003 340 4 CON ROD BEARING 463.39

411 141 623 2 PISTON COMPLETE 1514.96


14



SUGGESTED


SUGGESTED

RETAIL

COMPRESSOR SPARES Continued …….

411 011 000 0



ASA6283 GASKET KIT WITH OIL SEAL 204.20

411 042 340 4 MAIN BEARING BUSH 175.97

411 042 341 4 CON ROD BEARING PER HALF 63.55

411 034 501 0 MERCEDES 355


ASA5281 GASKET KIT INCLUDING OIL SEAL 141.83

ASA5410 RING SET 239.77

ASA6501 COMPLETE REPAIR KIT 810.63



411 042 620 2 PISTON COMPLETE WITH RINGS 1623.65

411 041 845 0


ASA5279 RING SET (75MM BORE) NLA



411 141 000 0 DEUTZ / IVECO / BELL COMPRESSOR 12640.69


411 141 205 4 MAIN BUSH 218.18

ASA5279 RING SET (75MM BORE) NLA


ASA6313 GASKET KIT 283.38

411 143 805 0 DEUTZ / IVECO COMPRESSOR On request

411 141 205 4 BUSH 218.18

811 408 040 4 OIL SEAL 62.76

897 316 999 4 GASKET 170.91

897 670 190 4 O' RING FRONT 5.91



411 145 507 0 MAN COMPRESSOR 10350.00

411 041 050 4 VALVE PLATE 182.04

411 041 051 4 LEAF VALVE 236.78

411 042 341 4 CON ROD BEAING PER HALF 63.55

411 141 623 2 PISTON WITH RINGS(75MM) 1514.96

411 145 000 2 GASKET KIT 806.15

411 145 653 2 CYLINDER HEAD 1291.23

411 151 008 0 MERCEDES S/S 4111510030 On request

411 154 002 2 HEAD 2982.97

911 501 624 2 PISTON & RINGS 1111.03

411 154 000 2 GASKET KIT 520.00

ASA6690 RINGSET Per Piston 85MM 257.50

411 154 003 0 MERCEDES ATEGO & BELL S/S 411 154 000 0 On request

411 151 052 4 GASKET FOR BARREL AND VALVE PLATE On request

411 154 000 2 GASKET KIT 520.00

411 154 002 2 CYLINDER HEAD 2982.97

911 145 738 2 CON ROD 411.45

911 501 624 2 PISTON AND RINGS (85MM) 1111.03



15



SUGGESTED


SUGGESTED

RETAIL

COMPRESSOR SPARES Continued …….

412 352 003 0 MAN COMPRESSOR 9200.00

412 352 001 2 GASKET KIT 752.47


911 145 738 2 CON ROD 411.45

911 501 624 2 PISTON WITH RINGS (85MM) 1111.03

412 352 924 2 HEAD L SHAPED HEAD 3900.00


412 704 008 0 TWIN CYLINDER COMPRESSOR (VOLVO) 17200.00

412 704 920 2 GASKET KIT 1512.99

412 704 932 2 COMPLETE HEAD 6703.21

911 501 624 2 PISTON WITH RING 1111.03

911 505 732 2 CONROD 621.84


412 704 014 0 COMPRESSOR FOR VOLVO FM 9 28040.44

412 704 933 2 HEAD 9107.96

911 501 624 2 PISTON WITH RING 1111.03

412 704 018 0 VOLVO COMPRESSOR (S/S 412 704 015 0) 31020.00

412 704 933 2 HEAD 9107.96

911 506 505 0 IVECO COMPRESSOR 22698.76

911 506 928 2 GASKET KIT 1461.61

A6608 RING SET X 2 303.07

411 141 623 2 PISTON WITH RINGS (75MM) 1514.96

ASA7073 COMPLETE REPAIR KIT 2390.48

911 504 506 0 TWIN CYL - DAF COMPRESSOR Replaces 9115045040 15780.69

911 504 920 2 CYLINDER HEAD 9110.64

411 141 623 2 PISTON WITH RING 1514.96

A6608 RINGS x 2 303.07

411 033 801 2 ADE 400 HEAD (THIN PLATE) - M/BENZ - kit only available


412 090 803 2 MAN COMPRESSOR HEAD ONLY NO GASKET 4052.04

912 510 103 0 AXOR TWIN COMPRESSOR 29600.00

912 510 920 2 CYLINDER HEAD 12356.79

912 551 001 0 NISSAN UD 460 NLA Replaced by 912 551 002 0 (Exclusive to UD)

912 551 921 2 CYLINDER HEAD 10734.57


M100960 TATA Single Cylinder 4462.65

M111410 Valve Plate 940.51

MSP1/226 RING Set 225.60

MSP1/216 GASKET KIT 470.25


16



SUGGESTED


SUGGESTED

RETAIL

SPIRAL BINDING

A900 SPIRAL BINDING (CLEAR) PER METRE 8.89

TEST EQUIPMENT -PNEUMATIC

1189386 TRAILER TEST KIT C/W GAUGES X 2 HOSES (6M) X 2 4501.44

453 004 007 0 WABCO TEST GAUGE 1190.72

AGA211 AIR GAUGE 0-10 BAR (DASH BOARD) 690.14

ASA5896* HOSE TEST GAUGE 423.86

TEST EQUIPMENT -ABS

SPEAK TO SALES COUNTER FOR NETT PRICING

ABS COMPONENTS -TRUCK AND BUSES

ECU'S

446 004 335 0 ECU 4 CHANNEL 24V E-VERSION 8175.00

ABS-SOLENOID VALVES

472 195 082 0 SOLENOID VALVE 12V FREIGHTLINER 1/2" LHS (472 195 078 0) 2500.35

472 195 083 0 SOLENOID VALVE 12V FREIGHTLINER 1/2"RHS (472 195 079 0) 2500.35

472 195 016 0 SOLENOID VALVE 24V (MAN) M22 Bayonet 2137.05

472 195 018 0 SOLENOID VALVE 24V (TRUCK AND BUS) M22 Voss Bayonet 2295.48

472 195 006 0 SOLENOID VALVE 24V (TRUCK AND BUS) 1/2" M22 Voss Bayonet 4677.54

ABS COMPONENTS -TRAILERS

ABS UNITS (ECU)

400 500 081 0 VCS II 24V (MIXED POWER SUPPLY) 2S/2M 4S/2M 4S/3M 7770.00

400 500 083 0 VCS II 12V 2S/2M 8660.00

ABS MODULATOR RELAY VALVES

472 195 031 0 24V M22 BAYONET 2381.14

472 195 033 0 12V 1/2" 2106.79

472 195 041 0 24V M22 BAYONET (BOXER) VCS1 6455.95

472 195 037 0 24V M22 BAYONET 2516.75

ABS SENSOR CABLES (TRUCK & TRAILER)

441 032 808 0 SENSOR -400MM 312.00

441 032 823 0 SENSOR -2000MM 750.00

441 032 851 0 SENSOR -1500MM 360.00

441 032 905 0 SENSOR BPW (DISC/CALIPER) 350MM Straight 782.00

441 032 920 0 SENSOR TRUCK STRAIGHT 2.5M 488.00

441 032 921 0 SENSOR TRUCK STRAIGHT 3.0M 498.00

449 712 023 0 VCS EXTENSION CABLE 2300MM 110.00



SENSOR BUSH

899 760 510 4 BRASS CUBE 49.80

MOUNTING BLOCK

ASA6241 SENSOR MOUNTING BLOCK 266.62

ABS CABLES AND POWER SUPPLY

449 423 060 0 SOLENOID VALVE EXTENTION CABLE -VARIO "C" -6M 598.71

449 423 120 0 SOLENOID VALVE EXTENTION CABLE -VARIO "C" -12M 709.06

449 615 030 0 DIAGNOSTIC CABLE VCSII -3M 574.75

449 616 158 0 3RD MODULATOR/DIAGNOSTIC CABLE 15/3M 1790.19

449 384 333 0 6M Y CABLE 12M STOPLIGHT POWER CABLE 2911.80

449 133 120 0 12M 7PIN ISO FEMALE SOCKET - SEMI TRAILER 2124.89

449 233 100 0 12M 7PIN ISO MALE SOCKET - DRAWBAR TRAILER 2658.77


17



SUGGESTED


SUGGESTED

RETAIL

ABS WARNING LIGHT

A6609 ABS WARNING LIGHT (ROUND -TANKERS) 107.19

EBS-D COMPONENTS -TRAILERS

CONTROL UNITS AND VALVES

480 102 010 0 MODULATOR (ECU) 4S/2M NLA

480 102 014 0 MODULATOR (ECU) 4S/3M WITH RSS NLA

480 102 015 0 MODULATOR (ECU) 4S/2M WITH RSS FOR TCE ONLY NLA

480 207 001 0 EBS 3RD MODULATOR VALVE (DRAWBAR) 5697.91

449 372 130 0 EBS 3RD SOLENOID CABLE - TRAILERS 2784.70

EBS-E COMPONENTS -TRAILERS

CONTROL UNITS AND VALVES

480 102 030 0 MODULATOR (ECU) 2S/2M 4 GIO 24V RSS 19484.47

480 102 080 0 MODULATOR (ECU) 4S/2M Multi Voltage ABS 12/24V RSS 24550.44

480 102 063 0 MODULATOR (ECU) 4S/3M 7 GIO + PEM 24V RSS 19517.50

480 207 001 0 EBS 3RD MODULATOR 24V (DRAWBAR) 5697.91

EBS E 3RD MODULATOR Multi Voltage 12/24V

EBS COMPONENTS -TRUCKS

AXLE MODULATORS

480 103 011 0 EBS AXLE (4X2) 1999 MERCEDES 13191.95




480 103 033 0 EBS AXLE (6X4) NISSAN UD 440 15556.43

480 103 042 0 EBS AXLE (6X4) DAF 15444.60

480 104 002 0 EBS AXLE 13661.16

480 104 003 0 EBS AXLE DAF 15874.12

BRAKE SIGNAL TRANSMITTER

480 001 000 0 ACTROS WITHOUT SILENCER M22 VOSS PORT 4 M16 7031.76

480 001 011 0 ACTROS WITH SILENCER WITHOUT SIGNAL PORT (4) M22 VOSS 6157.15

480 001 010 0 M22 VOSS PORT 4 M16 WITH SILENCER 6091.49

480 001 400 0 M22 VOSS NO PORT 4 WITH SILENCER (NISSAN UD440) 6832.41

480 001 500 0 M22 VOSS NO PORT 4 WITH SILENCER DAF 7018.08

480 020 003 0 CENTRAL BRAKE UNIT CBU MAN TGM On request

480 003 000 0 BRAKE SIGNAL TRANSMITTER 6084.14

EBS. ECU (ELECTRONIC CONTROL UNITS)

446 130 014 0 MB-ECU ACTROS 4X2 RIGID 6X2, 6X4 10360.00

446 130 015 0 MB-ECU ACTROS 4X2 9815.00

446 130 053 0 MB-ECU ACTROS MPII 11830.00

TRAILER CONTROL VALVE

480 204 002 0 T.C.U (MERCEDES IVECO DAF 75 85 95 SERIES) NISSAN 7633.98

SUPERCEDES "001 0" VERSION

EBS BACKUP VALVE

480 205 001 0 Backup Valve 3238.28

SLACK ADJUSTERS

433 576 502 0 Slack adjuster 5490.94

433 576 503 0 Slack adjuster 5490.94

433 506 103 0 Slack adjuster 2311.12


18



SUGGESTED


SUGGESTED

RETAIL

TATA SPARES AND COMPONENTS

M100960 TATA SINGLE CYLINDER COMPRESSOR 4462.65

M111410 Valve Plate 940.51

MSP1/226 RING Set 225.60

MSP1/216 GASKET KIT 470.25

M600781 FOOT VALVE (Not Stocked - only Repair kit)

MSP6/20 Repair kit 366.64

M600900 FOOT VALVE (Not Stocked - only Repair kit)

MSP6/23 REPAIR KIT 813.61

M304941 AIRDRYER 4486.00

MSP3/96 REPAIR KIT INCLUDES CARTRIDGE 1992.37

M305201 AIRDRYER WITH PROTECTION VALVE Diam: 110mm Leng:160mm 4486.00

MSP3/86 REPAIR KIT 410.51

M311700 CARTRIDGE ONLY 1411.94

M303510 AIRDRYER Diam: 130mm Length:120mm

MSP3/75 REPAIR KIT INCLUDES CARTRIDGE 1453.06

M311370 CARTRIDGE ONLY 1025.46

M302890 HAND CONTROL VALVE 2 PORT WITH LOCK POSITION 683.64

DIAGNOSTIC EQUIPMENT

ESSENTIAL EQUIPMENT

446 301 030 0 Diagnostic Interface & PC cable S/S 4463010220 8930.00

446 300 329 2 Diagnostic Cable for Trailer VCSI VCSII TCE EBS 1270.00

446 300 360 0 Diagnostic Inter Adapter CAN Cable EBS-E 6060.00

446 300 361 0 Diagnostic Cable CAN for 4463003600 above EBS-E 1760.00

446 300 430 0 Compact Tester: Truck and Trailer ABS replaces 4463004100 6450.00

446 300 400 0 Compact Tester V1,75 Vario C, VCS I and VCSII 5200.00

GENERAL SOFTWARE

446 301 501 0 Diagnostic Software for Trailer VCSI NLA

446 301 510 0 Diagnostic Software for Trailer VCSII 4040.00

446 301 542 0 Diagnostic Software for Trailer EBS D 4040.00

446 301 588 0 Diagnostic Software for Trailer EBS E 4890.00

446 301 589 0 Diagnostic Software for Trailer EBS E 4890.00

446 301 682 0 Diagnostic Software for Trailer TCE On Request

446 301 545 0 Diagnostic Software for Truck EBS (Europe) On Request

446 301 556 0 Diagnostic Software for Truck EBS (Asia) On Request

446 301 628 0 Diagnostic Software D+ ABS E Gen Hino Toyota 4050.00

446 301 547 0 Diagnostic Software for Daimler Chrysler (Actros) 4040.00

446 301 732 0 Diagnostic Software IVTM On Request

446 301 874 0 Diagnostic Software ENR Actros/Merc ECAS 4040.00

446 301 572 0 Diagnostic Software HPB BAE software 8120.00

446 301 692 0 Diagnostic Software ODR Tracker 4040.00

GENERAL DIAGNOSTICS CABLES

446 300 408 0 ABS/ASR E vers. Inter-Adapter Cable Hino Toyota 2630.00

446 300 327 0 ABS, ECAS Inter Adaptor 35Pin Old version Truck On Request

446 300 317 0 ECAS / ATC Inter adapter 25pin On Request

446 300 344 0 EBS Diagnostic. Asia Vehicles OLD Nissan UD On Request

446 300 401 0ND EBS Diagnostic. Nissan UD On Request

446 300 454 0 EBS (EPB) Cable MPII (Actros, Axor, defender) 4220.00

446 300 340 0 EBS / ECAS (EPB) Cable (Actros Axor) old cable On Request

446 300 345 0 ZBR MAN cable (TGA MAN ECAS etc) On Request

446 300 348 0 CAN (yellow trailer plug) and IVTM Cable On Request


19



SUGGESTED


SUGGESTED

RETAIL

STANDARD FITTINGS

UNIONS

893 800 294 0 M10-06 35.78

893 800 304 0 M10-08 79.42

893 800 014 0 M12-06 26.62

893 800 234 2 M12-08 24.11

893 800 044 0 M12-010 30.76

893 800 984 0 M12-012 54.65

893 800 064 0 M14-06 37.26

893 800 244 0 M14-08 30.76

893 800 073 0 M14-010 37.72

1677039 M14-012 94.44

893 809 010 0 M16-06 36.46

893 809 020 0 M16-08 39.38

893 801 994 0 M16-010 36.46

893 800 974 0 M16-012 54.60

893 800 022 0 M22-06 43.48

893 800 224 0 M22-08 40.97

893 800 109 0 M22-010 45.41

893 800 964 0 M22-012 61.97

893 800 033 0 M22-015 (STOSS) 90.01

ASA5223 M22-015 (SHORT) 67.40

893 800 264 0 M26-015 (STOSS) 109.38

ASA7077 M26-015 (SHORT) 133.17

893 800 254 0 M26-018 (STOSS) 170.91

893 801 000 0 1/8" BSP-06 35.41

893 800 371 0 1/4" BSP-06 50.00

893 800 904 0 1/4" NPT-08 37.60

ASA5128 1/2"BSP-012 (STEEL) 84.29

ASA931 1/2"NPT-012 95.10

ASA5182 1/2"NPT-012 (STEEL) 116.22

ASA5315 1/2"NPT-015 (STEEL) 109.38

893 800 354 0 1/4"BSP-010 43.30

ASA1347 1/4"NPT-010 63.81

893 801 314 0 1/4"NPT-012 (STEEL) 45.85

ASA1790 3/8"NPT-010 (STEEL) 56.97

ASA5208 3/8"NPT-012 41.02

ASA932 3/8"NPT-012 (BRASS) 79.67

ASA1025 3/8"NPT-015 109.72

ELBOWS

893 830 104 0 M12-08 (BULKHEAD) 127.34

ASA6503 M16-08 131.26

893 830 214 0 M16-012 (BULKHEAD) 118.08

893 830 770 0 M22-08 (BULKHEAD) 152.12

893 830 204 0 M22-012 (BULKHEAD) 86.00 117.36

893 830 042 0 M22-015 (STOSS) 165.21

ASA5225 M22-015 SHORT NUT 141.29

893 890 063 0 M22 (M) -M22 (FEM) 175.47

ASA1342 010SW-010 111.66

ASA1258 012SW-012 122.24

ASA1261 06SW-06 105.44

ASA1263 08-08 B/H 167.95

ASA1476 08SW-08 86.59

ASA965 1/2"NPT-012 (BRASS) 157.79

ASA6579 1/4" NPT-08 131.69

ASA5313 1/4"NPT-012 198.43

ASA963 1/4"NPT-012 (BRASS) 150.78

ASA1237 1/8"NPT-06 105.44

ASA1435 3/8"NPT-012 120.78

893 830 091 0 M26-015 (BULKHEAD) 262.06


20



SUGGESTED


SUGGESTED

RETAIL

TEES

893 860 053 0 010-010-010 152.27

ASA1504 010SW-010-010 141.29

893 860 374 0 012-012-012 (STEEL) 9 134.45

ASA1259 012-012SW-012 173.32

893 860 394 0 012-06-012 324.73

893 850 314 0 012-M22-012 281.99

ASA1260 012SW-012-012 152.81

ASA5258 012SW-06-012 143.72

ASA5207 012SW-TEST-012 339.15

893 860 014 0 06-06-060 104.26

ASA1345 06-06SW-06 140.75

ASA1336 06SW-06-06 161.73

893 860 194 0 08-06-080 162.57

893 860 144 0 08-08-080 152.68

ASA5242 08-08SW-08 182.30

ASA5443 08SW-08-08 118.50

A1012 1/2" HOSE TEE 64.44

A844T 1/4"(F)-1/4"(F)-1/4"(F) (T-BLOCK) 65.64

A636 1/4"(M)-1/4"(F)-1/4"(F) (T-BLOCK) 64.92

A637 3/8"(M)-3/8"(F)-3/8"(F) (T-BLOCK) 76.18

A6605 3/8"(M)-1/4"(F)-3/8"(F) 81.66

A6606 M16(M)-1/4"(F)-3/8"(F) 81.66

893 850 660 0 M16-012-012 161.79

893 850 324 0 M22-012-012 154.96

893 850 394 0 M22-M22-012 317.48

893 500 044 4 M22-M22-M22 163.06

BULKHEAD STRAIGHTS

ASA5366 012-1/2"BSP 129.76

ASA1009 1/2"-012 B/H (BRASS) 129.32

893 821 234 0 M16-012 129.27

893 103 900 4 M16-M22 (BODY ONLY) 75.30

893 821 224 0 M22-012 (BULKHEAD STRAIGHT) 76.34

893 890 040 0 M22-1/2"BSP 130.22

893 890 014 0 M22-M22 54.69

LINE CONNECTORS

893 820 024 0 010-010 39.38

893 820 160 0 010-010 (BULKHEAD LINE CONNECTOR) 96.54

893 820 564 0 012-012 52.41


ASA5231 015-015 (SHORT NUT) 86.59

893 820 061 0 015-015 (STOSS) 116.22

ASA5261 016-016 (SHORT NUT) 268.90

893 820 012 0 06-060 38.15


893 820 134 0 08-080 33.04

ASA5255 08-08 (BULKHEAD LINE CONNECTOR) 61.53

TEST CONNECTORS

463 703 106 0 M14 (FEM) 142.38

ASA5254 M16 (FEM) 137.53

463 703 114 0 M16 (M) 99.99

463 703 107 0 M18 (FEM) 180.57

ASA5207 012SW-TEST-012 TEE 339.15

463 705 102 0 1/4"NPT (MALE) 103.91

897 753 940 4 RUBBER DUST BOOT 22.61


21



SUGGESTED


SUGGESTED

RETAIL

'O' RINGS

897 071 110 4 M12 1.42

897 770 070 4 M14 1.54

897 770 250 4 M16-M18 1.13

897 080 400 4 M22 1.62

THRUST RINGS

893 030 070 4 M12 6.74

893 030 080 4 M14 14.00

893 030 014 4 M15 11.28

893 030 170 4 M16 5.38

893 030 020 4 M18 22.43

893 030 040 4 M22 5.92

LOCKNUTS

5000112 M8 2.06

5000113 M10 3.13

810 304 031 4 M16 (BOOSTERS) 10.82

810 315 004 4 M16 8.44

810 315 005 4 M18 9.00

891 500 454 4 M22 9.48

891 500 464 4 M26 15.72

891 500 520 4 M28 (EXHAUST BRAKE VALVE 3./2 WAY DIR. CONT. V) 130.72

A6001 M8 (NYLOC) 1.54

INSERTS

893 040 210 4 06L 1.91

893 040 220 4 08L 2.58

893 040 230 4 10L 3.18

893 040 240 4 12L 3.74

893 040 250 4 15L 4.93

CUTTING RINGS

893 050 014 4 06L 5.33

893 050 054 4 08L 5.85

893 050 024 4 10L 6.38

893 050 144 4 12L 7.75

893 050 034 4 15L 8.18

A5554 16L 13.69

893 050 040 4 18L 13.26

PIPE NUTS

893 070 054 4 06 (M12) 4.90

893 070 104 4 08 (M14) 5.55

893 070 834 4 012 (M18) 8.55

893 070 065 4 015 (LONG) 35.87

893 070 174 4 015 (SHORT) NLA

KOR'S

ASA5252 08-060 49.69

ASA1267 012-060 99.38

ASA1351 012-080 47.54

ASA1350 012-010 50.13

ASA5490 016-012 On request

ADAPTORS/HOSE TAILS

A23 1/2"NPT-1/2" HOSE 51.07

A24 3/8"NPT-1/2" HOSE 35.76

A25 1/4"-1/2" HOSE 27.45

A588 Ø12 PIPE STEM-1/2" HOSE 52.93

A646 M22-1/2" HOSE 80.52

4087055F M16 M HOSE ADAPTOR WITH O RING replaces 893 120 414 4 68.02


22



SUGGESTED


SUGGESTED

RETAIL

PLUGS

893 010 030 4 M12 23.18

893 010 011 4 M14 29.27

893 011 710 4 M16 32.17

893 011 711 4 M16 (FOOTBRAKE) 29.27

893 010 020 4 M22 47.18

893 010 230 4 M26 44.02

A174 1/8"NPT 11.48

A31 1/4"NPT 14.00

A30 3/8"NPT 14.00

A29 1/2"NPT 33.02

NIPPLES

893 100 035 4 M22-M22 34.46

893 100 164 4 M22-1/2"BSP 98.94

893 103 900 4 M16-M22 BULKHEAD ADAPTOR 75.30

893 890 014 0 M22-M22 BULKHEAD 54.69

893 890 040 0 M22-1/2" BULKHEAD 130.22

A60 1/4"NPT-1/4"NPT 28.95

A6217 1/2"-1/2"NPT 56.73

SOCKETS

893 240 224 4 M12 32.55

893 300 011 4 M22 (LONG) 62.67

893 300 012 4 M22 (SHORT) 38.82

W103/8 1/2"NPT 50.19

CABLE TIES

A1134 200MM PRICE PER BUT SOLD IN PACK OF 100 0.64

A6153 395MM PRICE PER BUT SOLD IN PACK OF 100 2.76

REDUCERS

893 180 034 4 M16 (M-M22F) 55.83

893 180 274 4 M16M-1/2"FEM 122.54

893 180 880 4 M26(M)-M22(F) 145.33

893 181 184 4 M22(M)-M16(F) 35.26

A34 3/4"NPT(M)-1/2"NPT(F) 52.64

A36 3/8"NPT(M)-1/4"NPT(F) 20.33

A39 1/2"NPT(M)-1/4"NPT(F) 41.00

A498 M22(M)-1/4"NPT(F) 35.00

A499 M22(M)-3/8"NPT(F) 35.00

A5379 M16(M)-3/8"NPT(F) 50.30

A6181 1/4"NPT(M)-1/8"NPT(F) 13.66

A672 1/2"NPT(M)-M22(F) 76.05

A673 M22(M)-1/2"NPT(F) 57.72

PIPE CLIPS / CLAMP

893 511 110 4 06 P-CLIP 17.90

893 511 030 4 08 P-CLIP 13.67

893 511 000 4 012 P-CLIP 10.35

893 511 010 4 015 P-CLIP 14.36

A5370 1/2" HOSE P-CLAMP 4.66

A6669 1/2" HOSE P-CLAMP (12 - 22MM) 9.52

A6183 1/2" HOSE P-CLAMP (16 - 25MM) 11.17

A6720 1/2" HOSE P-CLAMP (20 - 22MM) 26.62


23



SUGGESTED


SUGGESTED

RETAIL

PUSH IN FITTINGS

STRAIGHT UNIONS

893 803 035 0 M10 - 6mm (M10x1 thread) on request

893 803 022 0 M12 - 6mm (alternative 4100916M) 60.36

893 803 023 0 M16 - 6mm 65.07

893 803 024 0 M22 - 6mm on request

893 803 025 0 M10 - 8x1 mm (M10x1 thread) 76.10

893 800 007 2 M12 - 8x1 mm (8938034900, 4100888M) ** 54.69

893 800 001 2 M16 - 8x1 mm (8938035400, 4100911M) ** 52.02

893 800 005 2 M22 - 8x1 mm (8938034000, 4100913M) ** 66.09

893 800 002 2 M16 - 12x1.5 mm (8938034300, 4100915M) ** 54.75

893 800 008 2 M22 - 12x1.5 mm (8938034400, 4100914M) ** 73.39

893 800 004 2 M22 - 15x1.5 mm (8938037800, 4101056M) ** 87.05

893 803 420 0 M22 - 10x1 mm 93.09

893 803 410 0 M16 - 10x1 mm 84.87

893 803 990 0 M26 - 15x1.5 mm 270.31

893 800 005 2 M16 - 16 x 1 ** 66.09 Plastic Release Tool

** This type of fitting has pipe removable using a tool below

899 700 001 4 8mm Nylon Pipe Extraction tool plastic 29.53

899 700 002 4 12mm Nylon Pipe Release tool plastic 30.76

899 700 003 4 15mm Nylon Pipe Release tool plastic 34.76

899 700 012 4 8mm Nylon Pipe Release tool stainless steel 1133.70

899 700 014 4 12mm Nylon Pipe Release tool stainless steel 1133.70

899 700 015 4 15mm Nylon Pipe Release tool stainless steel 1133.70 Stainless Release Steel

MALE BULKHEAD BARREL TEE BLOCK

893 851 400 0 M22-M16F-M16F * (alternative 4101087M) 178.98

893 851 390 0 M16-M16F-M16F * (alternative 4101086M) 167.49

4101083M M12-M12F-M12F 98.12

* WITH Lock nut, Thrust ring and O ring

MALE BULKHEAD STUD BLOCK

4101005M M22 / M22 - M16F B/H stud * (alternative 8931042962) 111.66

4101017M M16 / M22 - M16F B/H stud * (alternative 8931042972) 67.82


MALE BULKHEAD ELBOW BLOCK

893 401 008 4 M12 - M12F B/H Elbow stud * on request



893 890 450 0 M22 - M22F B/H Elbow stud * 121.31

4101105M M22-M16F B/H Elbow stud 165.19



* WITHOUT Lock nut, Thrust ring and O ring

FEMALE TEE BLOCK

4100994M M12F - M12F - M12F TEE Block (alternative 8935010054) 141.97

893 501 191 4 M16F-M16F-M16F TEE BLOCK (alternative 4100993M) 59.25

893 501 197 4 M22-M22F-M22F TEE BLOCK (alternative 4101198M) 147.54


24



SUGGESTED


SUGGESTED

RETAIL

MALE BULKHEAD TEE BRANCH BLOCK

890 159 586 4 M16F -M22 - M16F TEE Branch * 213.83

4101096M M16F-M22-M16F TEE BRANCH (alternative 8901595864 *) 140.80

4101095M M16F -M16 - M16F TEE Branch (alternative 8935010014 * ) 136.61

4101091M M12F -M12 - M12F TEE Branch (alternative 893 501 006 4 * ) 136.73

A6605 3/8M - 1/4F - 3/8F TEE Branch (replaces A36 & A637) 81.66

A6606 M16M -1/4F - 3/8F TEE Branch 81.66

* WITHOUT Lock nut, Thrust ring and O ring

SCREW THREAD WITH SWIVEL PLUG

893 920 827 2 M 10x1 Swivel Plug P5 on request

893 129 191 2 M 12x1.5 Swivel Plug P5 47.85

893 129 192 2 M 16x1.5 Swivel Plug P5 41.63

893 129 193 2 M 22x1.5 Swivel Plug P5 52.56

SWIVEL PLUG ELBOW

893 401 827 2 M12x1.5 Elbow for P5 plug 62.38

893 401 015 2 M 16x1.5 Elbow for P5 plug 58.59

SWIVEL PLUG BARREL TEE

893 501 193 4 M12x1.5 Barrel Tee for P5 plug on request

893 501 194 4 M 16x1.5 Barrel Tee for P5 plug on request

SWIVEL PLUG BRANCH TEE

893 501 195 4 M12x1.5 Branch Tee for P5 plug on request

893 501 196 4 M 16x1.5 Branch Tee for P5 plug 145.21

BULKHEAD UNIONS

ASA7098 M16 - 12mm * 137.65

ASA7169 M22 - 12mm * (Alternative: ASA7100) 155.19

ASA7099 M22 - 08mm * 152.68

ASA7123 M22 - 12mm * M18 body 200.04

ASA7124 M22 - 08mm * M18 body 239.29


BULKHEAD ELBOWS

ASA7101 M22 - 12mm Swivel Type Short P5 plug (alternative: ASA7170) 210.25

ASA7102 M12 - 08mm * (Alternative: 893 831 291 0 * ) 151.86

ASA7103 M16 - 08mm Swivel Type Short P5 plug (Alternative: 893 831 293 0 *) 185.22

ASA7187 M22 - 15mm * 247.99


TEES

ASA7105 08-08-08 306.04

ASA7182 12-12-12 (Alternative: ASA7104) 297.57

ASA7106 15-15-15 (Alternative: ASA7183) 426.89

ASA7177 012-08-012 267.34

ASA7203 012-08-08 315.39


25



SUGGESTED


SUGGESTED

RETAIL

BRANCH TEES (ASSEMBLED)

ASA7107 012-M22-08 * (replaces: 8938510200) 279.42

ASA7109 012-M22-012 * (replaces 8938509700 and ASA7202) 245.04

ASA7164 08-M22-08 * 441.07


BARREL TEES (ASSEMBLED)

ASA7108 M22-012-08 * (replaces 8938510500) 243.06

ASA7110 M22-012-012 * 222.66

ASA7115 M12-08-08 * (replaces 8938510600) 202.20


TEST POINT TEES (ASSEMBLED)

ASA7111 M22 - TP - 08 * 270.30

ASA7112 M22 - TP - 012 * 260.74

ASA7113 M16 - TP - 012 * 259.91

ASA7114 M16 - TP - 08 * 271.99

ASA7097 M12 - TP - 08 * 230.16


LINE CONNECTORS

893 803 034 0 6mm-6mm 143.37

893 803 037 0 08mm - 08mm (replaces 4101064M) 139.08

893 803 039 0 12mm - 12mm (replaces 4101066M) 159.05

893 803 041 0 15mm - 15mm On request

VEE NUTS

893 771 236 4 VEE Nut 6x1 Pipe M12 54.22

893 771 234 4 VEE Nut 8x1 Pipe M14 54.22

893 771 235 4 VEE Nut 12x1.5 Pipe M18 82.62

O-RINGS

897 071 110 4 M12 1.42

897 770 250 4 M16 1.13

897 080 400 4 M22 1.62

THRUST RINGS

893 030 070 4 M12 6.74

893 030 170 4 M16 5.38

893 030 040 4 M22 5.92


26



SUGGESTED


SUGGESTED

RETAIL

VARIOUS

891 503 076 2 Locknut with O ring M22 On request

891 500 454 4 Locknut withOUT O ring M22 9.48

4101058M M16 M Test point (alternative 4637031140) 81.61

4101057M M12 M Test point (replaces 4637020030) 81.01

893 022 014 4 M16 M Plug with Oring (alternative 4101061F) 29.27

893 022 015 4 M22 M Plug with Oring (alternative 4087057F) 43.93

A6735 3/8" - 1/2" Hose Tail 46.49

4087055F M16 - 1/2" Hose Tail with Oring (alternative 8931294452 ) 68.03

4087063F M22 - 1/2" Hose Tail with Oring (alternative 8931294462) 71.83

ASA7127 M16M - 1/2"hose - 1/2" hose

893 104 058 4 M22 Bulkhead Stud ID M16 (alternative 4100992M) On request

(No Locknut)

899 360 210 4 Thread Filter M 12x1.5 On request

899 360 260 4 Thread Filter M 16x1.5 12.99

899 360 140 4 Thread Filter M 22x1.5 43.24

4101163M M18 - M16 Socket 59.24

A6717 M16 - 1/2" Socket On request


27

Documents

WABCO AUTOMOTIVE SOUTH AFRICA - Home - · PDF filewabco automotive south africa ... 432 410 083 0 airdryer with unloader 9.3 bar port 4/23 scania with heater 9100.00 432 410 001 2