Embed Size (px)
Citation preview
VOLVO
XC90 PREMIER
TP 39802022005
Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable curtain)
© Volvo Car Corporation
Warning!Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC in order to avoid:1. Personal injuries when performing repair work.2. Damage or malfunction of the SRS/SIPS bag/IC system.Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo workshop.In case of doubt, consult the SRS and SIPS bag/IC service manual.
Is the vehicle equipped with SRS/SIPS bag/IC ?Vehicles with SRS are most easily recognized by the letters SRS in the center of the steering wheel. If the vehicle also has a passenger side airbag, the letters SRS are stamped on the dashboard above the glove compartment. SRS vehicles from 1993 and onward also have explosive seat belt tensioners. SIPS bags are only installed on SRS vehicles from 1995 and onward. SIPS bag decals are located on the windshield and seat compartment. Vehicles with IC can be recognized by the letters IC on the C/D panel (4 door) or the B panel (5 door).
General recommendations• Be especially careful when working on or around SRS, SIPS, and IC components.• Make sure that no wires are pinched, frayed, or pierced.• Never fit accessories by the sensors.• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VADIS.• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VADIS.• Do not install any accessories in the areas between the A and B-pillars, the B and C-pillars,
and the C and D-pillars.
Test terminalFuse in cargo compartment auxiliary fuse box
Changes introduced up to and including June 2004Any changes made to the vehicle after this date are not included in the manual. If necessary, refer to service bulletins.
Volvo models are sold in versions adapted for different markets. These adaptations depend on factors such as legal requirements, taxation, and market demands.This manual may therefore include illustrations and text that do not apply to the vehicles in your country.
TP3980202 XC90 Premier 2005
Vehicles with SRS (Airbag)/SIPS bag/IC (Inflatable curtain) .......................................................... 2Abbreviations................................................................. 4How to use the wiring diagrams 1:2............................... 5Electrical distribution 1:2................................................ 7
FusesCargo compartment 11E & 11F...................................... 9
Ground connections31/10 - 31/118 ............................................................. 10
Group 39 OtherRear Seat Entertainment (RSE) 1:2 ............................ 11Cooler ........................................................................ 13
Connectors54/33 - 54/303 ............................................................. 1454/274 - 54/275 ........................................................... 1554/276 - 54/277 ........................................................... 16
Junction points53/403 - 53/521............................................................ 1753/522 - 53/731............................................................ 18
Cable harness routing in vehicleHarnesses, XC90 Premier ............................................19
Component illustrations1/1 - 3/1........................................................................ 204/9 - 11E ...................................................................... 2111F - 16/82 .................................................................. 2216/105 - 54/98.............................................................. 2354/274 - 54/303............................................................ 24
Index
List of components
Table of Contents
ExplanationsAbbreviations
TP3980202 XC90 Premier 2005 4
GroupsGroup 39 = Other
Ignition switch symbolsX = Accessories (audio position)S = Powered upon insertion of key15 = The switch remains connected during
start15l = Contact is broken while starting30 = Constant power from the battery50 = Start
Countries/MarketsA = AustriaAUS = AustraliaB = BelgiumCDN = CanadaCH = SwitzerlandD = GermanyDK = DenmarkE = SpainEU/OS = Markets outside USA and CanadaFIN = FinlandGB = Great BritainISR = IsraelJ = JapanKOR = KoreaN = NorwayNL = NetherlandsS = SwedenUSA = United States of AmericaWEU = Western Europe
OtherAUD = Audio Module (AUD)AUX = Socket for external equipmentCEM = Central Electronic Module (CEM)DVD = DVD playerMMM = Multimedia Module (MMM)RAS = Rear Audio Separation module (RAS)REM = Rear Electronic Module (REM)RSE = Rear Seat Entertainment module
(RSE)TFT = TV display in head restraint
ColorsBL = BlueBN = BrownGN = GreenGR = GrayLBL = Light BlueLGN = Light GreenOR = OrangeP = PinkR = RedSB = BlackVO = VioletW = WhiteY = Yellow
How to use the wiring diagrams 1:2
TP3980202 XC90 Premier 2005 5
The descriptions below apply in general to all wiring diagram manuals, although not all sections are necessarily con-tained in this manual.
A. Component designationEvery component has a component designation that consists of two parts.
The first part is a type number that describes the type of component in question, for example 3/xx.
The second part of the designation is a serial num-ber, for example x/2.
Combined these give a component designation, for example 3/2.
At the end of the manual is a list of components, where, with the help of the component designation, you can read off the name of the component, for example, 3/2 = light switch.
List of type numbersThe list shows which type of component that respec-tive type numbers refer to, for example, 3/x = switch, 6/x = electric motor, etc.
1 Battery2 Relay3 Switch4 Control module5 Driver Information Module6 Electric motor7 Sensor8 Actuator9 Heating element10 Light11 Fuse15 Electrical distribution rail/box16 Audio17 Service/diagnostics18 Contact reel19 Meter20 Ignition component/shunt26 Converter27 Optics31 Ground connection53 Junction point54 Connector
B. Junction pointsThe wiring diagrams contain numbered junction points, for example 53/352.
This manual contains a section with a list of junction points. This list shows all the components which are connected to each junction point.
The location of the junction points is shown in the "Cable harness routing in vehicle" section.
C. ConnectorsConnectors provide a bridge between two cable har-nesses and are described in the "Connectors" sec-tion.
D. Electrical distributionOperation of the fuses and relays is shown in the "Electrical distribution" section.
E. Data communicationToday’s cars are equipped with CAN & MOST net-works that transmit information. Connections to these networks are shown in their entirety on the respective wiring diagram. Complete information on CAN & MOST communication can be found in the section entitled "Control modules".
F. AbbreviationsA number of different abbreviations are used in the manual. These are explained in the section "Abbre-viations".
G. Component locationThere is a section at the end of the manual in which the appearance and location of components is described in numerical order.
TP3980202 XC90 Premier 2005 6
How to use the wiring diagrams 2:2
List of symbols
= System voltage
= Ground connection via wiring
= Ground connection on component/chassis
= Screened wire
= Junction point
= Twisted cable
= Electrical connection
= Variant
= CAN communication
= CAN high data signal(CAN H)
= CAN low data signal(CAN L)
= MOST communication
= LIN communication
= DIN cable, coaxial cable, etc.
= Data communication
= CAN communication
= Connection with distribution box
= Further connection to...
= Connector betweencable harnesses
= Connector connectedto component
CAN
1
1
A F B D E C
G
CEM
4/56
CAN
BL
15/20:13
3
5
2
1
4
R
2/80
1
23/10 RMI4
3
1
4/58
REM
A:1
SB
31/96
3
54/3LF15/24:2Y-GR Y-GR Y-GR
MAN
53/326
SB
MAN
11D/3
2
1 1
2
11D/4
30+
4/28
TCM
B:14
B:2
B:1
B:13
D:3
D:2
B:17
B:18
10/17
B:1
B:3
31/73
SB
SB
10/4810/55
A:14
A:16
53/604SB
53/601
SB
31/72
BL
54/51
1253/615
B:3
B:1
10/18
CAN
CAN
BL
BL
10/1-2
7
Electrical distribution 1:2
52
1 3
E
R
2
1
2
1
2
1
2
1
17/17
C6:2
C3:2
A1:1
C5:14
C4:11
C4:6
A1:5
C4:5
C2:2
C3:4
A1:10
A1:11
C4:9
C4:10
C4:2
C3:3
C3:1
A1:13
2/32
3
2/14
FMA2
52
1
FMA3
2
11A8
11B/20
11B/21
11B/22
11B/23
11B/24
B
R-W
SB
F
C6:4
C4:4
C4:3
C6:12
C6:13
C1:1
C1:2
R
R
A
BL
D
R
C
BL-R
Ov
TP3980202 XC90 Premier 2005
erview
452
1 3
452
1 3
2 5
31
11A 11A 11A
32
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
1
2
11
2
1
22
1
C6:1
C4:8
C6:9
C6:8
C5:15
FST1
2/91
FST3
2/90
7
22
11A6 11A
11B/14
11B/15
11B/16
11B/17
11B/18
11B/19
A1:6
C5:11
C4:16
A1:8
C4:12
C4:14
A1:3
C5:13
C6:3
A1:14
A1:2
A1:7
FMI1
2/22FMA4
2/35
C2:1
15/30
C6:7
5
2
11A4 11A3
2 222
21
11B/1
11B/2
11B/3
11B/4
11B/5
11B/6
11B/7
11B/8
11B/9
11B/10
11B/11
11B/12
11B/13
15/31
1
2
FST2
2/182
3
5
C5:12
C4:15
C6:10
C6:6
4
5 4
C4:1
A1:12
8
Electrical distribution 2:2
6/25:1
R
2
R
R
R-W
6/26A:1
E
/415
1
6 45
2 2
23
2 2
1
1/1
12V
+
SB
-
31/53
R
FSB
C:13
C:14
REM
CAN
LIN
4/58
R
R
R
VO
R
54/40C
1
2
K:1
A B DC
BL
R-W
BL-R
R
A:29
32 54/303
1F/2
R
11F/1
2
1
2
1
Ov
TP3980202 XC90 Premier 2005
erview
R
R
R
BL-R
11C/1111C/1
1 1
11C/2
2 2
11C/4
11
11C/3
1
11C/5
22 2
53/408
11C/8
1
11C/6
11
11C/7
2 22
1
11C/9
11
11C/10
2 22
43/1
R-SB
X
305
S
37
50
6
15
81
15 15I
16/65:1
BL-R
53/443
BL-R
BL-R
11C/1311C/12
1 1
2 2
53
4/9B:28/56
3/157:2
11E
7
2
D:16
B:2
B:24
B:3
B:16
D:8
D:15
4/56
CEM
D:60
CANVO
VO
BL-R
254/40D
2
VO
C:14
D:50
D:35
LIN
Y
Y-W
R
R
R
53/403
11C/14
1
2
1
E:A
E:B
R
R
R
R
BL
BL
4/9B:27/55
1
54/98
3 1
TP3980202 XC90 Premier 2005 9
11E Fuses by the battery
11F Fuses in cargo compartment auxiliary fuse box
No. Fuse function via A2 16/124 Rear Seat Entertainment module (RSE) - 40
No. Fuse function via A1 16/124 Rear Seat Entertainment module (RSE), 30 feed - 102 16/124 Rear Seat Entertainment module (RSE), X feed - 5
P2S04_11F
11F/1
11F/2
P2S04_11E
11E/3
11E/111E/2
11E/711E/5
FusesCargo compartment 11E & 11F
TP3980202 XC90 Premier 2005 10
31/10 A-post, right-hand side9/24 Coolbox rear seat9/25 Rear 12V socket9X/25 Connector, original car interface
31/84 A-post, right-hand side16/105 Audio Module (AUD)
31/118 Between the front seats below the armrest2/237 Disconnect relay, rear speaker16/122 Rear Audio Separation module (RAS)16/124B Rear Seat Entertainment module (RSE)
Ground connections31/10 - 31/118
AUD
16/105
A:1
16/3
2
1
11C/2
2
30+
1
B:6
B:11
B:3
B:10
B:2
B:9
B:1
B:16
B:8
B:5
B:13
B:12
B:4
R
6VO
GR-R
GR
W
SB-W
R-W
R
SB
GR
GR-R
GR
GR-R
11
3
10
2
9
1
16
8
16x/105
53/454
VO
VO
RAS
16/122
16/56
2
1
16/55
2
1
16/4
2
1
9
10
9
10
16/26GR
GR-R
GR
GR-R53/521
53/520
53/519
53/522
54/11
54/10
BN
GR-R
BN
GR-R
GR-R
GR
GR
GR-R
1
2
16/77
MIC
A:2
A:1W
GR
GR-R GR-R
GR
GR
GR-R
22
23
12
21
16/58GR-W
10
9
2 GR
1
1
16/5
GR2
GR-R1
2
16/57
2 GR10
9
1
16/6
GR2
GR-W1
GR-R1
2
54/43
54/21
54/20
54/40
13
5
16x/105
12
4
53/525
53/526
GR
GR-W
GR
GR-W
53/523
53/524
GR
GR-W
GR-W
GR
GR-W
GR
GR-W
GR BL
GN
BL-W
GN-W 10
9
11
8
1
2
W
BN
4
3
3
4Y 1
GN 2GN
Y
BN
W
16/125
IR1
2
4
3
53/448
31/84
BN
MMM
MMM
W/OMMM
A:2
BN
BN31
-LR
+LR
-RR
+RR
-LF
+LF
-CS
+CS
-RF
+RF
EXT. D
30
CAN
LIN
4/56
CEM D:37
EXT. DA:3F5
D:58
D:52
Rear Seat Entertainment (RSE) 1:2
Group 39 OtherTP3980202 XC90 Premier 2005 11
Group 39 OtherRear Seat Entertainment (RSE) 2:2
TP3980202 XC90 Premier 2005 12
TFT
16/82
DVD
16/81A
C:8
C:7
C:4
C:10
C:9
C:11
C:6
C:1
C:2
141110 1213 1516171854321 76 8 9 19 20
C:5
C:12
CONTROL BOX
Y-SPLIT
CN2
DVD
B:1
B:6
B:4
B:12
A:12
A:2
A:5
A:6
A:4
A:9
A:10
A:11
A:8
A:7
6
3
1
2
4
5
9
8
7
10
8
16/81B
1
TFT
5
4
2
3
7
6
10
9
54/274
9
10
8
4
7
6
5
2
3
1
5
6
8
10
9
7
1
3
2
4
54/276
6
2
1
4
3
5
54/277
10
8
7
9
54/275
A:6
A:2
A:4
A:8
A:7
B:6
B:4
B:5
B:7
B:8
A:1
16/123
AUX-panel
16/124
2 1
4
3 55
YELLOW
WHITE
RED
BL
W
BN
GN
Y
GR
P
BL
R
SB
VO
W
BN
GN
Y
GR
P
BL
R
SB
VO
VO
SB
R
BL
P
GR
Y
GN
BN
W
Y
GN
BN
W1
2
3
4
5
6
7
8
9
10VO
SB
R
BL
P
GR
BL
GN P
VO
GR
SB W R Y
BN
2 31 46 5
BN
W Y GN
GR
WBN
BL
GR
GN
Y
15
6
5
3
2
13
4
1
SB
VO
RY
53/731
2
1
4
318 GR
SB
R
31/118
SB
Y
BN
W
GN
SB
1 23 54/303
54/98
3
11E/2
30+
BL
BL
R
11F/1
R
VO
VO
VO
SB
Y-W
R
SB
CN1CN3
RAS
16/122
GR
2/237VO
11F/2
2
1
2
1
2
1
53/728
54/33
1
2
3
54/36
1
2
3
SB
SB
31/10
53/406
SB
9/25A:3
9x/25
F11
2
1
SB
R
9/24
SB
SB
9/25
D:12
Y-VO
SB
SB
Y-B
VO
Y/W
A:2 A:1
54/363 2 1
54/333 2 1
9/25A:3 A:2 A:1
B1 B3
1
2
SB
Y/W
10/72
CEM
4/56
CAN
3 2 1
1
2
Y/W
VOA:17
9/1
VO
1
2
VO
Cooler
Group 39 OtherTP3980202 XC90 Premier 2005 13
54/33 3-pin gray
No. Rear Seat Entertainment harness 12V outlet1 11F/2:1 Fuses in cargo compartment
auxiliary fuse box54/36:1 Connector
VOVO
- -
2 54/36:2 Connector Y/W - -
3 54/36:3 Connector SB - -
54/36 3-pin gray
No. Rear Seat Entertainment harness 12V outlet1 54/33:1 Connector VO 9X/25:1 Connector, original car interface VO
2 54/33:2 Connector Y/B 4/56D:12 Central Electronic Module (CEM)
9X/25:2 Connector, original car interface
Y/W
3 54/33:3 Connector SB 9X/25:3 Connector, original car interface SB
54/98 5-pin gray
No. Rear Seat Entertainment harness -3 54/303:1 Connector BL - -
54/303 3-pin gray
No. Rear Seat Entertainment harness Fuses in cargo compartment auxiliary fuse box
1 2/237:1 Disconnect relay, rear speaker BL 54/98:3 Connector BL
2 16/124(CN2)B:1Rear Seat Entertainment module (RSE)
VO 11F/2:2 Fuses in cargo compartment auxiliary fuse box
VO
3 53/728 Junction point R 11F/1:2 Fuses in cargo compartment auxiliary fuse box
R
54/33 - 54/303
ConnectorsTP3980202 XC90 Premier 2005 14
54/274 10-pin gray
No. TV display harness Rear Seat Entertainment (RSE) harness1 54/276 Connector W 16/124:1 Rear Seat Entertainment mod-
ule (RSE)W
2 54/276 Connector BN 16/124:2 Rear Seat Entertainment mod-ule (RSE)
BN
3 54/276 Connector GN 16/124:3 Rear Seat Entertainment mod-ule (RSE)
GN
4 54/276 Connector Y 16/124:4 Rear Seat Entertainment mod-ule (RSE)
Y
5 54/276 Connector GR 16/124:5 Rear Seat Entertainment mod-ule (RSE)
GR
6 54/276 Connector P 16/124:6 Rear Seat Entertainment mod-ule (RSE)
P
7 54/276 Connector BL 16/124:7 Rear Seat Entertainment mod-ule (RSE)
BL
8 54/276 Connector R 16/124:8 Rear Seat Entertainment mod-ule (RSE)
R
9 54/276 Connector SB 16/124:9 Rear Seat Entertainment mod-ule (RSE)
SB
10 54/276 Connector VO 16/124:10 Rear Seat Entertainment mod-ule (RSE)
VO
54/275 10-pin gray
No. TV display harness Rear Seat Entertainment (RSE) harness1 54/277:1 Connector W 16/124:11 Rear Seat Entertainment mod-
ule (RSE)W
2 54/277:2 Connector BN 16/124:12 Rear Seat Entertainment mod-ule (RSE)
BN
3 54/277:3 Connector GN 16/124:13 Rear Seat Entertainment mod-ule (RSE)
GN
4 54/277:4 Connector Y 16/124:14 Rear Seat Entertainment mod-ule (RSE)
Y
5 54/277:5 Connector GR 16/124:15 Rear Seat Entertainment mod-ule (RSE)
GR
6 54/277:6 Connector P 16/124:16 Rear Seat Entertainment mod-ule (RSE)
P
7 54/277:7 Connector BL 16/124:17 Rear Seat Entertainment mod-ule (RSE)
BL
8 54/277:8 Connector R 16/124:18 Rear Seat Entertainment mod-ule (RSE)
R
9 54/277:9 Connector SB 16/124:19 Rear Seat Entertainment mod-ule (RSE)
SB
10 54/277:10 Connector VO 16/124:20 Rear Seat Entertainment mod-ule (RSE)
VO
54/274 - 54/275
ConnectorsTP3980202 XC90 Premier 2005 15
54/276 10-pin gray
No. TV display TV display harness1 16/81A:1 TV display, LH head restraint W 54/274:1 Connector W
2 16/81A:2 TV display, LH head restraint BN 54/274:2 Connector BN
3 16/81A:3 TV display, LH head restraint GN 54/274:3 Connector GN
4 16/81A:4 TV display, LH head restraint Y 54/274:4 Connector Y
5 16/81A:5 TV display, LH head restraint GR 54/274:5 Connector GR
6 16/81A:6 TV display, LH head restraint P 54/274:6 Connector P
7 16/81A:7 TV display, LH head restraint BL 54/274:7 Connector BL
8 16/81A:8 TV display, LH head restraint R 54/274:8 Connector R
9 16/81A:9 TV display, LH head restraint SB 54/274:9 Connector SB
10 16/81A:10 TV display, LH head restraint VO 54/274:10 Connector VO
54/277 10-pin gray
No. TV display TV display harness1 16/81B:1 TV display, RH head restraint W 54/275:1 Connector W
2 16/81B:2 TV display, RH head restraint BN 54/275:2 Connector BN
3 16/81B:3 TV display, RH head restraint GN 54/275:3 Connector GN
4 16/81B:4 TV display, RH head restraint Y 54/275:4 Connector Y
5 16/81B:5 TV display, RH head restraint GR 54/275:5 Connector GR
6 16/81B:6 TV display, RH head restraint P 54/275:6 Connector P
7 16/81B:7 TV display, RH head restraint BL 54/275:7 Connector BL
8 16/81B:8 TV display, RH head restraint R 54/275:8 Connector R
9 16/81B:9 TV display, RH head restraint SB 54/275:9 Connector SB
10 16/81B:10 TV display, RH head restraint VO 54/275:10 Connector VO
54/276 - 54/277
ConnectorsTP3980202 XC90 Premier 2005 16
53/403
53/406
53/408
53/415
53/443
53/448
53/454
53/519
53/520
53/521
P2S04_53-403
1
11C/2
2
R
R
R
R
53/403
54/40C2
11C/9
1 1
11C/10
2 2
1
11C/11
2
11C/12
1 1
11C/13
2 2
1
11C/14
2
SB
SB
53/406
31/10
P2S04_53-406
9x/25:3
VO
VO
VO53/408
D:8
CEM
4/56
CAN
LIN
P2S04_53-408
3/1:63/157:1
4/9B:27/55
P2S04_53-415
11C/3
1 1
11C/4
2 2
11C/5
1 1
11C/6
2 2
1
11C/1
2
R
R
R
R
53/415
54/40C1
BL-R BL-R
BL-R
BL-R
BL-R
53/443D:16
CEM
4/56
CAN
LIN
P2S04_53-443
3/157:2
16/65:1
4/9B:28/56
3/1:1
BN
BN
MMM MMM
W/O MMM
BN53/448
31
AUD
16/105
31/84
P2S04_53-448
VO VO53/454
16x/1056
P2S04_53-454
4/56A:3
EXT.D
GR-R GR-R
GR-R
53/519
P2S04_53-519
16/55:1
16/4:1
54/10 9
GR GR
GR
53/520
P2S04_53-520
16/55:2
16/4:2
54/10 10
GR-R GR-R
GR-R
53/521
P2S04_53-521
16/3:1
16/56:1
54/11 9
Junction points53/403 - 53/521
TP3980202 XC90 Premier 2005 17
53/522
53/523
53/524
53/525
53/526
53/728
53/731
GR BN
BN
53/522
P2S04_53-522
16/3:2
16/56:2
54/11 10
GR-W GR-W
GR-W
53/523
P2S04_53-523
54/40 10
154/20 16x/10512
GR GR
GR
53/524
P2S04_53-524
54/40 9
254/20 16x/1054
GR-W GR-W
GR-W
53/525
P2S04_53-525
54/21 1
954/43 16x/10513
GR GR
GR
53/526
P2S04_53-526
54/21 2
1054/43 16x/1055
R R
R
53/7281 RAS
16/122
P2S04_53-728
16/124B:6
54/303 3
SB SB
SB
SB
53/73113 RAS
16/122
31/118
P2S04_53-731
16/124B:12
2/237:20
Junction points53/522 - 53/731
TP3980202 XC90 Premier 2005 18
TP3980202 XC90 Premier 2005 19
1
2
3
11E/2
54/33
54/274
54/36
2/237
54/275
16/105B
16/124C
16/124B
54/303
54/98
11F
16X/105
16/123
16/124
16/122
1. Rear harness2. Rear Seat Entertainment (RSE) harness3. TV display harness
Cable harness routing in vehicleHarnesses, XC90 Premier
1/1 Battery
2/14 Relay, glow plug unit
2/22 Relay, climate control system
2/32 Main relay, engine management system
2/35 Starter motor relay
2/90 Relay, windshield wiper, low/high speed
2/91 Relay, intermittent wiping
2/182 Relay, headlight washer motor
2/237 Disconnect relay, rear speaker
3/1 Ignition switch
P2S04_1-1
P2S04_2-14
FST1
FMI1
RX
R
FMA
3
R FMA
1
X
FMI3
FMI4
FMI2
FST2
FST3FM
A5
FMA
2FM
A4
P2S04_2-22
FMI1 FMI2
FST1
XR
FMA
3
FST2
R FMA
1
RX
FST3
FMI4
FMI3
FMA
5
FMA
4FM
A2
P2S04_2-32
FMI1
FST1FM
A1
R
FMA
3XR
XR
FMI4
FMI2
FMI3
FST2
FST3
FMA
2FM
A4
FMA
5
P2S04_2-35
FMI1 FMI2
FST1
XR
FMA
3
FST2
R FMA
1
RX
FST3
FMI4
FMI3
FMA
5
FMA
4FM
A2
P2S04_2-90
FMI1 FMI2
FST1
XR
FMA
3
FST2
R FMA
1
RX
FST3
FMI4
FMI3
FMA
5
FMA
4FM
A2
P2S04_2-91
FMI1 FMI2
FST1
XR
FMA
3
FST2
R FMA
1
RX
FST3
FMI4
FMI3
FMA
5
FMA
4FM
A2
P204_2-182
FMI1
FST1FM
A3X
RX
RR FM
A1
FST2
FMI2
FMI3
FMI4
FST3
FMA
4
FMA
5
FMA
2
P2S04_2-237
P2S04_3-1
1515
50X 15I
S 30
Component illustrations1/1 - 3/1
TP3980202 XC90 Premier 2005 20
4/9 Control module, Supplementary Restraint System (SRS)
4/56 Central Electronic Module (CEM)
4/58 Rear Electronic Module (REM)
6/25 Starter motor
6/26 Alternator
9/1 Front 12V socket
9/24 Coolbox rear seat
9/25 Rear 12V socket
10/72 Front ashtray lighting
11E Main fuses at battery
P2S04_4-9
P2S04_4-56
P2S04_4-58
6 7 8
321 4 5
9
3703456r
26232425
29
16
2728
13 1514
2030
2221
1817 19
37
38
1110 12
36
31
3332 34 35
P2S04_6-25
P2S04_6-26
P2S04_9-1
ACREAR
*
PQRS
GHI
CD
1
7
4
6864
7672
688064
7276
80
POWER
EMULOV
AM FM
#0
3
WXYZ
MNO6
9
DEFABC2
TUV
JKL
8
5
SOUND
LE CTE OS R
MY KEY
EXIT
MENU
ENTER
P2S04_9-24
P2S04_9-25
P2S04_10-72
P2S04_11E
11E/3
11E/111E/2
11E/711E/5
Component illustrations4/9 - 11E
TP3980202 XC90 Premier 2005 21
11F Fuses in cargo compartment auxiliary fuse box
16/3-4 Speaker, front right door & front left door
16/5-6 Door speaker, rear right door & rear left door
16/26 Speaker instrument board center
16/55-56 Tweeter, front left door & front right door
16/57-58Speaker, LH & RH D-pillar
16/65 Antenna ring/ignition switch illumina-tion
16/77 Microphone, mobile telephone
16/81ATV display, LH head restraint16/81BTV display, RH head restraint
16/82 DVD player, rear
P2S04_11F
11F/1
11F/2
P2S04_16-3-4
P2S04_16-5-6
P2S04_16-26
P2S04_16-55-56
P2S04_16-57-58
P2S04_16-65
7 1
P2S04_16-77
P2S04_16-81-A-B
P2S04_16-82
Component illustrations11F - 16/82
TP3980202 XC90 Premier 2005 22
16/105 Audio Module (AUD)
16/122 Rear Audio Separation module (RAS)
16/123 External equipment socket AUX
16/124 Rear Seat Entertainment module (RSE)
16/125 IR transmitter
31/10 Ground connection
31/118 Ground connection
54/33 Connector
54/36 Connector
54/98 Connector
P2S04_16-105
P2S04_16-122
P2S04_16-123
P2S04_16-124
P2S04_16-125
P2S04_31-10
P2S04_31-118
P2S04_54-33
P2S04_54-36
P2S04_54-98
1
1 5
5
Component illustrations16/105 - 54/98
TP3980202 XC90 Premier 2005 23
54/274 Connector54/275 Connector 54/303 Connector
P2S04_54-274-275 P2S04_54-303
Component illustrations54/274 - 54/303
TP3980202 XC90 Premier 2005 24
TP3980202 XC90 Premier 2005
AAbbreviations ...............................................................................4
CColor abbreviations ....................................................................4Component illustrations ......................................................... 20Connectors ................................................................................ 14Cooler .......................................................................................... 13Countries/Markets, abbreviations ..........................................4
EElectrical distribution overview ...............................................7
FFuses in cargo compartment, 11E & 11F ...........................9
GGround connections ............................................................... 10Groups ...........................................................................................4
HHow to use the wiring diagrams .............................................5
IIgnition switch symbols .............................................................4
JJunction points ......................................................................... 17
LList of symbols .............................................................................6
OOther, Group 39 ....................................................................... 11
RRear harness ............................................................................ 19Rear Seat Entertainment (RSE) ......................................... 11Rear Seat Entertainment (RSE) harness ........................ 19
TTable of Contents .......................................................................3TV display harness ................................................................. 19
Index
26
1/1 Battery
2/14 Relay, glow plug unit2/22 Relay, climate control system2/32 Main relay, engine management system2/35 Starter motor relay2/90 Relay, windshield wiper, low/high speed2/91 Relay, intermittent wiping2/182 Relay, headlight washer motor2/237 Disconnect relay, rear speaker
3/1 Ignition switch
4/9 Control module, Supplementary Restraint System (SRS)
4/56 Central Electronic Module (CEM)4/58 Rear Electronic Module (REM)
6/25 Starter motor 6/26 Alternator
9/1 Front 12V socket9/24 Coolbox rear seat9/25 Rear 12V socket
10/72 Front ashtray lighting
11E Main fuses at battery
11F Fuses in cargo compartment auxiliary fuse box
16/3-4 Speaker, front right door & front left door16/5-6 Door speaker, rear right door & rear left door16/26 Speaker instrument board center16/55-56 Tweeter, front left door & front right door16/57-58 Speaker, LH & RH D-pillar16/65 Antenna ring/ignition switch illumination16/77 Microphone, mobile telephone16/81A TV display, LH head restraint16/81B TV display, RH head restraint16/82 DVD player, rear16/105 Audio Module (AUD)16/122 Rear Audio Separation module (RAS)16/123 External equipment socket AUX16/124 Rear Seat Entertainment module (RSE)16/125 IR transmitter
31/10 Ground connection31/118 Ground connection
54/33 Connector54/36 Connector54/98 Connector54/274 Connector54/275 Connector54/303 Connector
List of components
TP 3980202 (US English). Printed in Sweden, Gothenburg 06-2004
