37
The Ultimate In Style & Performance ® Exeter, PA St. Catharines, ON 1-800-800-8586 www.pridemobility.com Owner’s Manual

US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

  • Upload
    others

  • View
    2

  • Download
    0

Embed Size (px)

Citation preview

Page 1: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

�������������� �����������������

������������������� �� ���������������������������������������������������������������������� ��!�"��

Owner’s Manual

Page 2: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

S A F E T Y G U I D E L I N E S

���������� �����������������������������������

��������������������������������������������������������������������������������������������������������������������������������������� ���������!����������������������������� �������������������������

"���������������������������������������������������������������������� ������� ��������������������������������"���������������������������������������������������#����������$������������� �������������������%���� ������%�� ���$�������������������������������������������������#��������$������������������������������������������������������� ������� ���������������������������������������������������������#��������$����������������������������������������&����������#����������$��������������

'�������������������������������������������������������������������������� ������� ������������������������%����������������������������������������������

����������� ����������������������������� �������� �������������� �������������������������� ����������������������������������������� ������������!"

#��$�%&�'�� % ���� ������� � � ��� ��� ���������� �� ���������"� �� ��� ��� �������������������������� ��� ��� ������������������(������������) ��������� ��������������� ��������� �� ����������!"

*�&+�,�%-$��% ������������ � ��������� ������"�% ������������ � ������������������������������������������ �������"�*�������������� ����������������� ������ �����������������(������������) ����������������������� ���������������������� !"

�&%-.�/ ���������������������� �������� ���� ������������� ���) ������"

Page 3: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

3

C O N T E N T S

�� ����������� ������������������������������������������������������������������������������������������������������������������������� �

��� �� �� ����������������������������������������������������������������������������������������������������������������������������������������� (

���� ������ ���������������������������������������������������������������������������������������������������������������������������������������� )*

��� � �������� ������������������������������������������������������������������������������������������������������������������� )+

�� �������� � ���������������������������������������������������������������������������������������������������������������������� �

��� ���� �� ������������ �������������������������������������������������������������������������������������������� �,

���� �� ������ ������������������������������������������������������������������������������������������������������������������������������� �*

������������������ �� ������������������������������������������������������������������������������������������������ �-

��� ��� ���������� ���� ������������������������������������������������������������������������������������� ,

�� ���������� ������� ��������������������������������������������������������������������������������������������� ,,

��� �� ���������� ��� ������������������������������������������������������������������������������������������������ ,.

���� �������� �������������������������������������������������������������������������������������������������������������������������������� ,(

Page 4: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

4 www.pridemobility.com Sonic/RevA/May 2004

I . I N T R O D U C T I O N

SAFETY/01�2�0������������������������������3�����4�'�������������%���������������������5��5��5�������������������� ������ ����������������/�������������������������5�����������%��������������%������������&���������������������%�����"��������������������������������������������������������������������������������������������%����

����������������������� �������� ��������������������������������������������������������������������������������������������������� ������������������������ ���������������%���� �����6�� ����������������������������������#��������

����������������������������������������������������� ���������!��������������������������������������� ���������������������7����������%������� ���������������� ������� ��������� ������������� ���� ������������������������������� ������������������� ���������� ����������������������� ���� ��� �������������������

INTERNET AND PRIVATE PURCHASES'��������������������������������&����������������������������������������������$����������7����������%������������������������������������������������������������������������������������������

�����������������������%��������������������%�����������������%����!�����������������������$���������������������� ������%���������������������������������7����������%�����

PURCHASER’S AGREEMENT TO ENSURE SAFE OPERATION8�������������%�������������� ��������������������������� ���� �����������������������%������������������������������������ ������� �����������������������������9���� ������ �������������������������6����������������%���������������������������%����������������������

PRODUCT INFORMATION'���������������������������������������������������������������������%��������������������������/������%����������6�����������������������������:���������������������������������%��������������������������� ���������� �&��������� �������������������������������������������%�����������

Page 5: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

5Sonic/RevA/May 2004 www.pridemobility.com

I . I N T R O D U C T I O N

INFORMATION EXCHANGE/�������������!������� ������� ���������������������������/������������6��������������������������������������������� ������������%�����������%����������������7����������%�����

��������������������������������� �������6������������������������������������������ ���������� ��������������������������������������������#��������������������������������������������������;

�����������������������������:�;�����������<�������)+�=��!�������:%��0&��� �:)+(�,5�(-�

�����������>����������������+ �����+� .

PRIDE OWNERS CLUB:���������������������� ��������������������������������2�����������������������������������������������������������%��������?�����������������������������:����������������� ����������%��������� �����%��������������������%� ����������%�����%����������������������������������� ������������ �����������

@�������������� �����A2���������A�����������������������������������������������������B���������������������%���� ������ �������������� �������%������ �����������������������5��� ����������%���������������'�������������������%���������������������������������5��������������������������%���������%����������������������!�������������������������%��

��������7����������%����;

C���;DDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDD

:������;DDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDD

�����C�����;DDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDD

��������<��;DDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDDD

�&%-.������ ��0��������������������� ������ ������������������������ ����������� ���� �1�������� ������������������������������ ��������������������"

Page 6: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

6 www.pridemobility.com Sonic/RevA/May 2004

��������� ��������'����������������������������������������������� �������������� ����������������������%����������������������������������������������

*���� ���������0������ ������������� �������������������� ���� �������������0��������������� ����������������� ���������������0������"

2���������������0������"

3������������������� ��������"

����4��4������ ������������"

-#�4��4�% ������� ��� ������������������������������ �������0�����56�7(�"

��������������� ����������������� �������8���� �"

*��� (9� � ���������������� ������������"

#:�� ������������� �"

$������ ���������� ���1������(�����1� �����1������ �������������������� �����������"

I I . S A F E T Y

Page 7: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

7Sonic/RevA/May 2004 www.pridemobility.com

$����������0�����4����� ����"

�0���� �:��� ��� ��� ���1� ����1� ���1� ���1� ��� �������������� ���0��� ��������"#����������������������������������������"

����0�������� ������������������������������� ;��"������������1����������������������0���<4������������������������������ ����� 0����54���������� ������"��� ������ ������ ������ ����������������� �����(����������������"

*��0��������������� �������) �����������"�$�����������������:���������������� ���9($9����0���������� ���������� ����"

9������0��� �������������������������"�3����������#�������49������������������ ���� ��������������������:�����0������������"

-:�����0������������"

9��������� ����������� �������������� ���"

3����������#�������49������������"

I I . S A F E T Y

Page 8: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

8 www.pridemobility.com Sonic/RevA/May 2004

I I . S A F E T Y

GENERAL

B���������������5��5��5������5������������%������������������������������������%�������&��5��%�%��������������������������%��������������������������������������������������������������������������������������������������������������������������������������������������������6����������������������$������������������������3���� ������������ ��������������� ���4�

'��������������������� ����������������������������� �����������������������������������������������������������������������������:�����������������������������������������������������������������������������������������������%�������������%������%�����

:��������������������������������������%���� �������������������������������������������������������������=������6���������������������������������������������������������%���������������� �������������%���� �������������� ����%����������������

8��������������������� ��� ��������������������������������������������������������������������������������

MODIFICATIONS�������������������������������������������%�����&��������������������E���%�� ���������������������������������� ��� ����%� ������������������ ��� ����������������������

���������$��������������� ������������������� ���������������� � ���������������������� ������������� ��������8���� �"

ELECTROMAGNETIC FIELDSB����������������������������������������������������������������������������������������5����������������������%���� ����������5���������� �����������%����������� ������������������6� �������%�������� �������������������

���������$��������������� ����������������������� � ���;������*����"�3� � ���;��������������������� ����������������� �����(������������� ���������"

REMOVABLE PARTS

���������$���������������� ����������0���� ������������������� ��������0��������"*���������� ��������������� ���������������� ��"

Page 9: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

9Sonic/RevA/May 2004 www.pridemobility.com

I I . S A F E T Y

PRE-RIDE SAFETY CHECKF��6���������������������������������������������������������������������������6����������������6���������������������������������������@�������������������������������������������� ���G��H������������������I

�������������������������������������������������;� ����6��������������������3���!���������������������4�� ����6�������������������������6����������������������������� ����6�����������������������6���������������������������� ����6�����6���� ����6����������������������%���������� ���������������7����������%�����������������

INCLINE INFORMATION����������������������%������������������������������������� �����������������������������=�������������%���������������6�3)+ 5����������4����!����������%���������������6������������������ �����������&�������������������������������������������������������� '�6����������������������������������������������������� ������������������������

�������������� ���������������� ������������������������������������������� /������%������������ 6��������������������#����������������������������������

����������������������� :%���������������������

WEIGHT LIMITATIONSB���������������������&�����������������J��������������������������������������

TIRE INFLATION���������������!��������������������� �������������6����%������������������6���������������6��������������������������������������������������������������������������������������������

����������������������������������� ��<64<=��������������� ��������������������� ��������������������"�$������ ���������������0����������� �������"��2�������� ��������� ��������������������1�����0�������������������� ���"���� �������������<64<=��������������� �������� ���������������������������� �������������(���� ������� ��1�� ���������� ������������ �����(������������� ���������"

������������������ �������������������������� ���������� ������� ���0����������� ��� ��"������������ ��������������� ���� ���������� ������ ����0���������� ��1���� ���������� �����������(�������������� ��"

���������-:��������� ������ ���������0������� ������������������ ���������������� ���������������� ���������"�*����������������� ����������������������� �������(�������������������� �������������� �����������0������ ������������"

���������$�������������������������� ���������"�9����������������������� ���������������� �����(����������������"

Page 10: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

10 www.pridemobility.com Sonic/RevA/May 2004

I I . S A F E T Y

/�������������������� ���6���������������%��������������� ���������������� �������������������������/������%���������������� ��������������������#�����������������������������%����������������������������������������������%������������������������������������������� �������������������������������������������������%���'����������������������%����������������������������������������������

��������������������������������������������������������� ��� ������ ���������� ��>����� ���� ��������������� �������������������� ������������1���� ������������������� ��"

���������� ���������������������1��������;��;��������0����������� ��� ���������� ��������"��$��0���� ��������������� �� ��� ���������"�% ������������� ����� ����������������������������"��������:��������:������� ������ �����������������������"

���������$���������0���� ����������������� �������������������������������� ���������� ���?������������1������������1�� �������0���� �������������������"

���������'� �� � ���������0��� ���������������������� ;��� ������������"�"1������0�������� �����1����1�� ������1����������0��!"

����������� �������������������������������������1���0��������� ������������������ ��������� �����������������������������:�������"

���������-0���� � � ��� ���������������������������������������������� ��� ������ ������������� ���>�������1� ������������ �������1��:������ ����������� ���������������� ������������������������������� ����� �"�$���������� ���� ������������������� ��������1���� �������������������� �����(������������� ���������"

E��������������������������������#�����%���������������������������� ����������������������������������������������������������2������������������������ �����5���� ���������������������������������@�����)��������������������������������������������������������%������������������������������������������������

'���������������������������������������������������������#������������������������������������������������"����������������������������B��������������������%�������������������������������� ����������������� ����������������������������� ������������������

8˚9˚250 lbs.

6˚300 lbs.200 lbs.

9˚150 lbs.

Figure 1. Maximum Recommended Incline Angles

Page 11: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

11Sonic/RevA/May 2004 www.pridemobility.com

I I . S A F E T Y

CORNERING INFORMATION0&�����%���������������������������������������������������@������������������������������������������ �������������� �������������� ������������3����������������������4 ���%�������������� �������������������� ����������������������������������������������3��������������������������������%������K�������������������������������4 ��������������������������E�������������������������������������������������������%����������� ������������������������������3���� ������������������������4����%�����������������������

���������� �������������� ����1���� ����� �������"�� ��� ������� ������������ �� ��������1���������������� ����"�% ������������� ����� ����������������������������"�%��0�������������� �������������������1�������:��������������������� ������������"

Figure 2A. Increased Stability Driving PositionFigure 2. Normal Driving Position

/����������������������� �������������������=��������������:�'��������������������%�������������������������������������������������%����������

BRAKING INFORMATIONB������������!������������������������6�������;

� J��������%�;"��������������������������%�������������������������%����������������$�����������

� <������68��6�;:��%����������������������������%����6����������%�������������� �����������������%��������������������������

Page 12: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

12 www.pridemobility.com Sonic/RevA/May 2004

I I . S A F E T Y

Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach

OUTDOOR DRIVING SURFACESB�����������������������%������������������������������%������������L��� ��%�������������5�������������� ����6�� ���������E���%�� ������������7�����������������������������������5������������������@����������� ������������������������������������������6������ ����� ������%���@������������������������������������������6������

� J�����������������������������%��������%�����������$��������������� :%��������������������������������������������� :%�������������6�����%����������� �����������������������%���������� �%�������������

���������'� �� � ���������������� �������������� ����������������������"��,������ ����������������� ����������������������� �� ����� ��������������� ���������"�&����������������������������� ���"����� ������� ���� ������������������1����� �������������� �:������� ����"

PUBLIC STREETS AND ROADWAYS

STATIONARY OBSTACLES (STEPS, CURBS, ETC.)

���������$���������0������������� �����1� �����������������1���(�������4������� ���1���� ��1������1����"!"

���������$���������������� 0���� �������������������������������������� �� �������������� �� "�/���� ������������� �����(�������������� ��"

���������$���������������� 0���� �������������������������������������1�� ��1����� ����������"��% ������� ���� ��������������������� �������������� ��"

���������,��� ����� ���������������0��������������� ���������� ����� ���������) �����������������������"��/������ ����<����<�"

���������$��������������������������� ���� �� ��� ��� ���������� ��5���"

Page 13: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

13Sonic/RevA/May 2004 www.pridemobility.com

I I . S A F E T Y

FREEWHEEL MODEB������������!���������������������������%���� �������������6 ������������������������@�������������������������������������������������������������� ���M�HB���=������I

���������� ����� ��������������������� ��������1�� ����������������������������"��$��������� �����0�������������������0���� ����"��-�� ���� �������������0��������� ����������� "��/������ ����� ������������������������������������ ��������"����0������������������������������� ��"���������� � 0������� ���� � ������ ���������1��������� ���������� �����0�������������������� �������"

�� ������ ����� ����0���� ������ ����������������� �����(������������� ���������"

INCLEMENT WEATHER PRECAUTIONS

:�������������������������������H�����������I���������������������������������������������&�����%���������������������������

H����5��5���I�����������������������������������������������&���;

� ����6�����������H���I�������������������� ����������������������%������������%����6����������������������������������&����������������������������������������������� ����������������������������%������

� ����6�����������H��I�������������������� ����������������������������������������������'������%�������������������������������������������������������������%������%������������������������%������������

���������*����� ������������ ���� ����������������� ���������� ��� ��������������������������������������� ��������"�"1�������������!"�/ � � ��������� ���������������1����������� ��1�����0�������������� ��������������������������� ���������"

���������$������������������������ ����������� ��������������:��������������������� ��������������� � ������1�����1�����1��������������;����������� ������ � ��������������� ��������(0������!"������������������������ �������������� � �������������������� ������������������������������� ���������������������"

Page 14: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

14 www.pridemobility.com Sonic/RevA/May 2004

I I . S A F E T Y

DOORS� <���������������������������������������� "����������������6�����������������������5����� <��%������������������������������������������������2����%�������������������������

������������������������

ELEVATORS���������%������%�������������������������� ���������� �������������3�4�� ��������������������������%�������������3�4����������� ������������������������

�������������������������������������������������������� "�����������6����6� ���6���� ���������������������������������������%���������

LIFT/ELEVATION PRODUCTS�������������%������������������ ����������������������������$���%�����������������������5����������������������������������%��������������� ������������� ����������������������������������������������$���%������������������������������

�����������0������������ ����������� ��������������� ��������������������� ���������������(���0��������� ��"��'� ������������������������������� � � ��1����������������� ������ ����������� � � ����������� ��������������������*����"

STAIRS AND ESCALATORS=����������������������%���������������������������:�������������%����

���������$������ ����� ���������������������������������������"�'� ����� ������ ������� �������������� ������(���������� ���������"

BATTERY DISPOSAL AND RECYCLING���������������������������6������� �����������������������������������������������7����������%����������������������������B���������7����������%��������������%�������������������5������������������� �����������������������������������

BATTERIES���������������������������������� �����������������������������������������������

����������/������������������� �0������������������������������!"�2����������� ���������� ����������� ������ ����������������� ��"�������������1��������������� �������������������� ������������������������� "

���������,������ �����1� ��������1� ��� ������� ����������� ������� ���� ��� �������� ���"���� � ��������� ������"

������������������������ ��������������������;���������0���� ��������;���������"9 ����������;���������������� ����������������� �����(������������ ��������"

����������-$��@!�������� �������������������������0���@!����������������(�����"��,2�9A�4!�������� ������������������������0���4!����������������(�����"���� ��������������� ������������������� ��������������������� ����������������� �����(������������ ���������"���-*2�9-��������������������������"

Page 15: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

15Sonic/RevA/May 2004 www.pridemobility.com

I I . S A F E T Y

GETTING ONTO AND OFF OF YOUR SCOOTERF���������������������������!������������������������������������%��������������������������������������������������;

� 0�������������������������������������=��M�HB���=������I� ��6�������������������6���������������6��������%��������6��������� '�����������������������������6��������������������������������

���������*���������� ������������������������������ ��������������������0����� �������������������������� �������� ��"

����������0���� ������� ������������������ ���������� ������"�/ � � ������� ��� ��������������������� �������������� ��"

����������0����� �������������� ������ ������ �����������"�/ � � ������� ���� �������������������� �������������� ��"

�������������� ���������������������������������������������������:��������������������1�� �������� �������"�% �����������0���� ��:����������������������0�������� ����������������0���������"���� ������������������ ����������������� ��"

PREVENTING UNINTENDED MOVEMENT

MOTOR VEHICLE TRANSPORT�������� ����������������������%�������5���������������%���%�������������������������������������������������

:����������������������!����������������������� ����������������������%��������������������������%��������������:�������%������������%�������������������������������������%�������������������������������������

���������$��������������� ����������� ����������������0����0� ����"�*���������� �����(���������������������� ��"

������������������� ����� ����������������������������������������� ����� ������������������������"���� ������������������ ����������������� �����(������������� ��������"

REACHING AND BENDING:%����������������������������%��������������/����������� ������� ������������������������������� ����������������������������������%�����6��������������������������������������������������������������$���������������������������������������������������������������!������������������������������

���������$����������1����1������� ������������������ � 0����������� ��� �������� ������������� ������������������� �������"�#�0�������� � ���� �������� ������ �������������0�������� ������ ��������� ��������� �������������� ����� ����������������1������������ �������������������� ��"�A������ �� ������������� ��������� ������0���"

Page 16: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

16 www.pridemobility.com Sonic/RevA/May 2004

I I . S A F E T Y

PRESCRIPTION DRUGS/PHYSICAL LIMITATIONS'����������������&���������������������������������������$����������'��������������������������������������6����������������%��5��5����������������������������������������������������

��������� 9��� ��� �� �� � ������� ��� �� � ��� ������ ����������� ��� �0��4� �4�� ���������������������� � 0���������� ����������������"�/��������������������������������������� ��������������������� �����������������������"

ALCOHOL'����������������&���������������������������������������$����������'����������������������������������������������������������������

���������$��������������� ����������� ������ ���� ������ ������ ����������� ��1��� �������������� ���������������0�������"

POSITIONING BELTSB���������7����������%���� �������3�4 ��������������������������������������������������������������!�������������������������������������������������������

��������������� ���) ���������������������������������������� ���������1������ ������������������� ����"�/���� ������������� ��������� �������� ����������� ���������"

Page 17: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

17Sonic/RevA/May 2004 www.pridemobility.com

I I I . E M I / R F I

ELECTROMAGNETIC AND RADIO FREQUENCY INTERFERENCE (EMI/RFI)1�������������%��������������������������������!�������%�������%�����%�������������������������������������5��������������%��������'��������������������������������������������������� ��������5���������3���������6��5��6���4 ����������� 'M������ �����������3E:�4����5����� ������������������6� �������%�������� ������������������������������ ������%���������������������%�����

% ������� ��� ����������������� ��������������� �������0������56�7(�"

*�&+�,�%-$��%�����0���� ������������0�����1�� �������� ������������ �������������4�����������������0� ������������ ������������ ���1����4�������1���4���1��������� �������������������������"

���������% �������������4�����������������0� ������������������� ���� ����������������� ���������������0�����������������1�� � ��������������"

�&%-.����� �� �����������������-#�(��1����������"�������������"���"����� ���������������������������������� ��1�� ���� ��������� ����������������������������������"�9��*�������B664C5C4B56=������������ ����������"

Page 18: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

18 www.pridemobility.com Sonic/RevA/May 2004

21"

34"

17"

16"

22"- 29"

37"

Turning Radius

1.75"

12"

31" - 32"

12" - 13"

Figure 4. Sonic Dimensions

I V . S P E C I F I C A T I O N S

2" FRONT TIRE

7.5"

2.5" REAR TIRE

Figure 4A. Sonic Tire Dimensions

Page 19: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

19Sonic/RevA/May 2004 www.pridemobility.com

Model Numbers SC50Colors Red, BlueOverall Length 37 in.Overall Width 21 in.Total Weight Without Batteries 93 lbs.Heaviest Piece When Disassembled 35 lbs.Turning Radius 34 in.Speed (maximum) Variable up to 4.25 mphRange Per Charge* (With 12 AH batteries) Up to 10 milesGround Clearance 1.75 in.Weight Capacity 300 lbs.Standard Seating Type: Foldable molded plastic

Dimensions: 17 in. width 16 in. depth (usable) 12 in. height (usable)Material: Charcoal fabric

Drive System Rear-wheel drive, sealed transaxle, 24 volt DC motorDual Braking System Electronic, regenerative, and electromechanicalTires Type: solid; front: 2 in. x 7.5 in

rear: 2.5 in. x 7.5 in.Battery Requirements Type: Two 12 volt, deep cycle (AGM or Gel-Cell)

Size: 12 AHWeight: 9 lbs. each

Battery Charger Off-board charger

I V . S P E C I F I C A T I O N S

NM����������������� ��������� ����������� ������������� ���������������

Page 20: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

20 www.pridemobility.com Sonic/RevA/May 2004

TILLER CONSOLE'����������������������������������������%����������� ������������������#��������� 6������� �������������%�� ����������������� ����10< ������������=��������.�

����������$�������:������ ������������������������� ��"����� ���0����� ��� �����������������������������:�������������� ��1��������������������������� ���������� ������ ���������������� ��������� ��� � ��"

V . Y O U R S C O O T E R

Key Switch� @�����������6�������6���������������3�����4������������ J���%���6��������6�����������������3������4�����������

Throttle Control Lever'�����%���������������������������������������%����������������������������&�����������������������������#����������� ���������������������������������������������������������������� "�����������������������������������%���������������������������6�������%���������� J����������%������������������������������������������������������������������%��

���%�����%������ /������������������%��������������������� ��������������������������H���I����������

����������������������6���

Horn Button'��6������������������������6������������������������������� '����������%����������������� <�������������������������������������������%�������������#����

Status LED'������10<���������������������������������������������������'��10<�������������������������������������������������%����������������������� ������10<���������������=��G�H8����'������5�������I����������������������10<����������������������������� ���������������7����������%�����

BATTERY CONDITION METER

HORN BUTTON

STATUS LED

KEY(INSERTED INTO KEY SWITCH)

SPEED ADJUSTMENT DIAL

THROTTLE CONTROL LEVER(REVERSE)

Figure 5. Tiller Console

THROTTLE CONTROL LEVER(FORWARD)

��������������� �����������0������� ��D���E����������� ������ ����������������������1�� ���������������������������������� ��������������������������� ��������

Page 21: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

21Sonic/RevA/May 2004 www.pridemobility.com

V . Y O U R S C O O T E R

Speed Adjustment Dial'����������������������������������������������������� '���������������������������������������������� '������������������������������������������

REAR SECTION'�������������������%�� ���5�������� ���������$�����&������������������������������5����������������=��������(�

Manual Freewheel Lever/����%�������������������������������������������� �������������������������� '�������������������%���������������

������������������� ���������������������������������%���

������������%��������������6�������� B������������������������ �����������������������%��������������5

���������%���������6�������9����6������������������������������

���������� ����� ��������������������� ��������1�� ����������������������������"��$��������� �����0�������������������0���� ����"��-�� ���� �������������0��������� ����������� "��/������ ����� ������������������������������������ ��������"����0����������

��������������� ��"���������� � 0������� ���� � ������ ���������1��������� ���������� �����0��������������

� �������"

�� ������ ����� ����0���� ������ ����������������� �����(������������� ���������"

Anti-Tip Wheels'�����5������������������������������������������������������<��� �������������������� ����%������5�����������������������

����������$����������0��� �����4����� ����������������� �������������������� �������� � ���;������*����"

Motor/Transaxle Assembly'������$�����&��������������������������������������%����������������������������������������������������������������������������%�������������������

Figure 6. Rear Section

MANUAL FREEWHEEL LEVER

ANTI-TIP WHEELS

MOTOR/TRANSAXLEASSEMBLY

Battery Condition Meter'��������������������������������������������������&������������������������

Page 22: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

22 www.pridemobility.com Sonic/RevA/May 2004

V . Y O U R S C O O T E R

OFF-BOARD BATTERY CHARGER'�����5����������������� �������������������5�������������������������������������5�� �������������������������=��������+�

Figure 8. Off-Board Battery Charger

BATTERY CHARGING COMPONENTS'��������� ���5�������������������� �����������������6��3��������4��6����������������������������=��������*�

Batteries (Not Shown)'���������������������������������������������������'�����������!��������������������%���������6����������������������������'�%�������������6 ����%���������������������

Off-board Battery Charger Port'�����5�������������������������������������������������5���������������������

Main Circuit Breaker (Reset Button)/�����%���������������������������������������������������%��������������������&�����%�������������������� ����������������6��������������������������������������������� '����������������6��������������������������6�������� /���������6������ ������������������������������������������� :����������������������������������������H����I� �������������������������������������6���� ������������������6���������!����� �������������������������������������B���������

�������%�����������7����������%����������������������������������������� ������������������6��������������� �������������7����������%����������%����

Figure 7. Battery Charging Components

OFF-BOARD BATTERYCHARGER PORT

MAIN CIRCUIT BREAKER(RESET BUTTON)

BATTERIES (UNDERNEATH BATTERYCOMPARTMENT LID)

CH

AR

GE

POW

ER

PLUGS INTO OFF-BOARDBATTERY CHARGER PORT

PLUGS INTO STANDARDWALL OUTLET

Page 23: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

23Sonic/RevA/May 2004 www.pridemobility.com

V I . B A T T E R I E S A N D C H A R G I N G

B�����������!�����������5������ )�5%�� ����5�����������������������������������������'����������������������5������������������������� ��������������������������������������������������� O�������������������������6����������������������������

������������0��� ������:������������������ ������� ���������� ����"��*� ��� ��� ���������������������������������������������� ����"

��������������0������ ����� ��������������������������������� ;��"�������������1����������������������0���<4������������������������������ ����� 0����54��������� �������"���� ������ ������ ������ ����������������� �����(����������������"

���������-�� ���� ����� ���������� ��� ��������������������������������������� ������� ��� ���������������������� �����4������������� �������������� ������������"

@�����������������������������������������;)� ������������������������������������������ J���%���6��������6��������,� ��6����������������������������%�����������%����������� ���������5�������������������������5���������������������������������(� ���������5�������������������������������������/���������������������������������

+�)�������*� /��������������������������� �����������������������������������������������������5

���������������������

�&%-.�% ��������� ������� ������ ������������ ���������"��% �������������������� ������ ����������������������������������������� ����� ��������������� �����"

Figure 9. Battery Condition Meter

READING YOUR BATTERY VOLTAGE'��������������������������������������������������&���������������������������������������F������������������������������� ��������������������� ����������������������������������������������=��������-�'����������������������� �������������������������������6����������������������������������������� ��%����������

CHARGING YOUR BATTERIES

@��������������������������65�����������������������������&��������������������%��������)� @������������������������������������������� 2�����������������������������������������<��%������������ ���������%���������������

�����������������������������������%�������������������������������������,� @������������������������ 2���������������������.� @���������������������������(� :�����������%��������������� ����������������������%����������) P���������6�����������

��%����������������������&�����������������

Page 24: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

24 www.pridemobility.com Sonic/RevA/May 2004

V I . B A T T E R I E S A N D C H A R G I N G

FREQUENTLY ASKED QUESTIONS (FAQS)

��������������������� /��������������������%���������� ������������6������� �������������������������������������������������������:����������������������������� �����������������������������������������/��������������������������� ���������������������������������7������������'����5���� ������������������������ �������������������������������������� ���������%������������/����������������������������������������������������������������%�������

!���� �������������"����� �������������� � 0����������3Q4�������6354����������������������������������������������� 0������������������������������������������������

#���$������� ��������������� @��������� ����������� ���������������������������������������� �����������������������������������������������������������������5������������������

�������������$������������"����� �� '����#��������������������������������������������������������������������;� :����������������������������� �����!�����������������������

/������������������������� ���������������������������������������������������������������������/��������������5�����������������������������%����������������������������E��5�%�� ���������������������������������������������������������������������������������������������������@��������������������������������%�������������������������������������������� ����������������������� �����������������������������������������������B���������������

�������������������%�����������������%����/�������������������������������������������+�)�������������������

� ��������������������������6������ ����������������������������6���)��)������������� O������������������������������������ :%����������������������������������������

�������$����������% ����"�������� �� @���������������5���������������%��������������������������&���������������O���������������������������������������%�����������8��������������������������������������� �����!������������ ��������������������������������������������� ����������������������������������������%��������

!�����"�����"� ������������ � �������������������������������������������� ���������������������������%��������5%���������������������������!���������

Page 25: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

25Sonic/RevA/May 2004 www.pridemobility.com

�������$�������% ������������ ����������������� ���������������� ��������� ����������������������������� ��������������������������� ������������������������������� ����������������� ��������������������������������� ���������������������������������������������������������������������������������������������������������������������������������������������������� :��������������������������������������������������� �������&'�&(��� ����������� �������������������%�������������� ����6�� ���6�� ������������������������� 1���������������������������������� '�������������%��������������������������������� :%������5���5�����%����

!������������� )����"������������$���� /��������������5�����������������������������������������8��:F����F��5�����������5��������������������������������������<��������5����������� �������%�����%���������

�&%-.�/������������������������0������"��$����������0��� �����"

"������������������������������������������������7����������%����;

!�����������"����� ������������ <���5����������������������������������������������������������������� ���6��5��������������3������4 ������������������������<���5���������������������������������������%�������� ������������������� �����������������%���!���6���������

/����6���������������������������������%�������������������������������������������������������@���������������%��������������������������������������������������<������������� ������������������������������&�����������������������������������������E�����������������������������9������������%����������������&��������������������������������

�����6���������������������������������������������������7������#��������������������������������

��6��������������������3��������������������������������������4���������������������������������������������������5���������������6�����������������������

V I . B A T T E R I E S A N D C H A R G I N G

����������9������0��� ������������������������������"��3����������#�������49������������������ ���� ��������������������:�����0������������"

BATTERY SPECIFICATIONS*���+

, )�+-�����+

.�������+

<���5�����3:F���F��5����4

)�:E)�%�������

)�:E

Page 26: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

26 www.pridemobility.com Sonic/RevA/May 2004

V I . B A T T E R I E S A N D C H A R G I N G

BATTERY REPLACEMENT

Battery Removal)� J���%���������������������=��������) ��� <�������������������������=��������))�,� J���%�����������6�������������=��������)):��� "�7������������6�������%������������������.� <�������������3Q4�����%��������6354�����%������������������������������������������

�������������������������=��������)��

��������� �,�����������1� ��������1� ��� ������������������ ������� ������� �������� ���"���� � ��������� ������"

Battery Replacement)� ����������3�4������������������������������=��������)��� J�������3Q4�����%�����������8���6�����354�����%���������

�� ���������������������6�������������6���������������������������,� R������������6������������6���������������������� J������������������������.� J��������������������������

Figure 12. Battery Leads

Figure 10. Battery Compartment Lid Figure 11. Battery Harness Removal

Figure 11A. Battery Pack Removal

BATTERYTERMINAL

BATTERY LEADS

BATTERYHARNESSES

Page 27: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

27Sonic/RevA/May 2004 www.pridemobility.com

BEFORE GETTING ONTO YOUR SCOOTER� E�%�������������������������S=��M��H8������������������I� ���������������������%���������%��������SC�%�����%��������������������%�����������������

��������������������������������������� $������� �����������"� ��������������� � � =���G�H<�������������:��������I

GETTING ONTO YOUR SCOOTER)� ��6�����������6��������%��������6��������

�� =�����������������������,� ��6�������������������6���������������������� ��������������������������������������������.� ��6����������������������������������������

PRE-RIDE ADJUSTMENTS AND CHECKS� :�������������������������������S� ���������������������S� ����������������������S� ��������������������������������6�����������������S=��M����H������:�#�������I� ����6�������������������6�������S=��M�HB���=������I� <��������������������6��������S� ������������������������������ ��� �����������S� E�%���������������������%�����%�������������������������������������S

OPERATING YOUR SCOOTER

����������% ����������������0����������������������������������� ��������������� ��������.����+������������������ �������� ���������� �������9���������������������� ���������!��+���������������������� ������������%���������������� � ��������� ���������;���0� ����

/ � ������������ ���� ���������������������(����������1���� �������������������� �����(������������� ���������"

O����������������������������������������������������������������������������'������%������������%�����������������%������%�������� =����������#���������������������������� ����������������������������������������������������%���� '�������������������������6���6�����������������������������������������������������

������������������������������#����������� ������������������������������������������ �������������������������������������������

V I I . O P E R A T I O N

������������0������������������������ ������������� � ������������0����� ������������ ���������� "��% �����������0����� �����������������0����������������� �����������������0���������������"

Page 28: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

28 www.pridemobility.com Sonic/RevA/May 2004

V I I . O P E R A T I O N

� ��%���������������������������%�������������� J���������������������%��������������������������������� '�������������������������6���6��������������������������������������������

�&%-.�'� ���������8����0���������������������� ��� ������ ����������������� ���������� �� ���������� ����������"

GETTING OFF OF YOUR SCOOTER)� 8����������������������������� J���%���6��������6��������,� ����������������������������������������������������

POWER DOWN TIMER FEATUREB������������!�������������������%��������������������������������������������%��������������������������������6�������%���6������6��������������H��I����������������������������������&������� ������ �������������������������������:�������������������������� ���������������������������������������

������������������������6������� ��������������������������������������������)� J���%���6��������6���������� J��������6�����������������������

Page 29: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

29Sonic/RevA/May 2004 www.pridemobility.com

SEAT HEIGHT ADJUSTMENT'��������������������������������������������=��������)��)� J���%����������������������� "��������������������������%�����5

�����������������������,� J����������������������������������

����������� /��������������������������������

����������#����������������������������������

.� @�������������������(� J������������

SEAT ROTATION'�����������������������������������- T����������)� ����������������������� J��������- T��)+ T�������������

�����������������,� 1������������������ � �� ���6�� ���

��������

Figure 14. Seat Height Adjustment

ADJUSTMENT HOLES

UPPER SEATPOST

LOWERSEAT POST

DETENT PIN

V I I I . C O M F O R T A D J U S T M E N T S

TILLER ANGLE ADJUSTMENT

B������������!�������������#��������%����������)� '������������#�����6�������������6�����������

��������=��������),��� ��%����������������������������,� '������������#�����6�������6������������������

����������

�&%-.� � ��� ������ ��� ������ � �� ������� ��� � �������������1��� �� �������������0��� �����"����0��� ���������� �������������� �� ������������ ���������"

Figure 13. Tiller Adjustment

TILLERADJUSTMENTKNOB

�������������0��� ������������ ����������� ���������� ������� ������������� �����"��0��������������� ���� ������������� ������� ����� ����������������������"

Page 30: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

30 www.pridemobility.com Sonic/RevA/May 2004

DISASSEMBLYC����������!��������������������������������������:�����������������������������������������%�� ������������������������������������6�O������������������������������������������6����������������������������������

I X . D I S A S S E M B LY A N D A S S E M B LY

B���������������������������������������;����� ������������ ������������ �������������6�=��������).�

8�������������������������� ����%���6�����������������������������%���������%�3�������4��������

)� 1��6���������������������������������66�������������������6����- T�=��������)(�'������������������������������������6��������

�� J���%���������������������������,� J���%����������������������������������������� "�����������5�5��������������������������������=��������)*�

LOCKEDPOSITION

Figure 16. Tiller Lock knob (Locked) Figure 17. Wiring Harnesses

BATTERYHARNESSES

FRONT-TO-REARHARNESS

Figure 16A. Tiller Lock Knob(Unlocked)

UNLOCKEDPOSITION

Figure 15. Disassembled Scooter

BATTERY PACK

REAR SECTION

SEAT

FRONT SECTION

����������2����������� ����������� ��� ��������������������� ����������������� ��"������������������ ����������������������������������������������� ���������"

Page 31: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

31Sonic/RevA/May 2004 www.pridemobility.com

Frame Separation)� �������6�������������%����������������6������������������%����������������=��������� ��� 1���������������������������������������������������=���������)�,� ������������������������%�����������������������������=�����������

Toggle Latch Release)� �������������������������������������������6������������=��������)+��� ���������������������6���%��������������������=��������)-�,� 1����������������������������������������������������#�����6����

I X . D I S A S S E M B LY A N D A S S E M B LY

Figure 19. Toggle Latch (Unlatched)

TOGGLELATCH

TOGGLELATCHRELEASEBUTTON

Figure 18. Toggle Latch (Latched)

TOGGLELATCHBUCKLE

Figure 20. Frame Positioning Figure 21. Frame Lockup

PEGS

SLOTS

Figure 22. Frame Halves

TILLER HANDLE

Page 32: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

32 www.pridemobility.com Sonic/RevA/May 2004

ASSEMBLY)� ����������������������������������������������������������� "���������������������������������������������������������������������������������5

������������������������������=���������)�,� E�������������� ��������%�����������������������������%�����6�������6�������������5

���������������������=��������� ��� J���������������������������������#�����6����.� =�����������������=��������)+�� 1������������������6���� �������6�������������������6����������

(� ������������5�5��������������������������������*� J��������������������������+� J���������������������������6����������-� "����6�����������������������������66���- T����������6�����=��������)(:�

���������������������������� ������������������ ������������� ������������������������� �� �������������������������������������������� ���������"

I X . D I S A S S E M B LY A N D A S S E M B LY

Page 33: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

33Sonic/RevA/May 2004 www.pridemobility.com

:��������������������%�����!�����������������������������E���%�� ���������������������������������%���������������������������������������������������������������������������������������������������������������������������������������������

DIAGNOSTIC FLASH CODES'������������������������������������������������������������������������������!���6������������:�������������������������������������10<�����%������������������������������%������

�&%-.��'� �������������������� �� ������� ����� ������������������������0������� ��������� �������� ��������1�� ���� �����������"

X . B A S I C T R O U B L E S H O O T I N G

FLASH CODE CONDITION SOLUTION

n nBatteries are too low to operate the scooteror the charger is operating.

Charge batteries or unplug the charger power cordfrom the electrical outlet.

n n nThe scooter’s battery voltage is toohigh to operate the scooter.

Insert the key into the key switch, turn thescooter’s light on to drain power from thebatteries.

n n n n nSolenoid brake trip: the manual freewheellever is in the freewheel position.

Turn the key to the “off” position, then push themanual freewheel lever to the (forward) driveposition, restart your scooter.

n n n n n nWigwag fault; your throttle control lever isnot responding.

Call your authorized Pride Provider for assistance.

n n n n n n nSpeed pot fault: speed adjustment dial isnot responding.

Call your authorized Pride Provider for assistance.

n n n n n n n n The scooter’s motor is disconnected.Check the front-to-rear harness connection—callyour authorized Pride Provider for assistance.

n n n n n n n n nPossible controller trip-the scooter is hotand the scooter seems to be losing power.

Shut down your scooter for a minimum of severalminutes to allow the controller to cool.

!���� ������������������������������������"��/��0 � ��6�����������6���������������������6��������� ����6���������������������������=��M��H8������������������I� ����������������������6�������������=��M�HB���=������I� ��6���������������������������3������������5�5����4������������������� 8��������������������������������������%����@��������%���6��������6����������

���������6�����6�����6��������

!���� ���������������"��������������������� � B���������������������������������������� /����������������������%������������������ �����6���������������������������������$

�����&�������� �����������������������%����������������%���6��L���������6�����6�����6��������

��������������������������������

!���� ������"��������� � �������� ��������������������������������� �����������$����������������������������� � @������������������������������=��M��H8������������������I� E�%�����������7����������%��������������������

������&��������������������������������������������������%� ���������������7����������%����������������� ���������� ������%����

Page 34: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

34 www.pridemobility.com Sonic/RevA/May 2004

X . B A S I C T R O U B L E S H O O T I N G

!���� �������� ��� ��� ��"��������� ������������ � ������������������������������!������=��M��H8������������������I� ������������������ ��%���������������������������������������������7����������%������ =��M��H8�����������������I���M�H=������������I��������������������������������������� ����6��.5���������������&�������������6�������

�����%������������������63�����4;� J���%���������������������������� 0&���������������������������=����������,������� �����������������������������

Figure 23. Working Fuse Figure 24. Blown Fuse

Page 35: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

35Sonic/RevA/May 2004 www.pridemobility.com

B�����������!����������������������������������������������������������������������������������������������������� �������������������������������������������������7����������%�����'������������������!������������������������$��������������������

TIRE CONDITION AND TREAD WEAR� J���������������������������������������������� "���������������������������������������������������������%�����

��������� �$������������ �����������������������������?�� ������� ���� ����������������������� ������������"

EXTERIOR SURFACES� 8�����������������������������������������������������������%���������������

��������� �$������ ���� � ����� ��� 0����� ������������ ��� � �� �������8�� ���� ���� 0����!1���������1�������������"���% ���������������������� ������������������� ���������������� �����(������������� ���������"

� '�������������������������������:8=���������������������%������������������������� :���������������������&���������������������������������

WIRING HARNESSES� J������������6��������������������������������������� E�%�����������7����������%������������������������������������� ��������� �������������

����������������������������������

AXLE BEARINGS AND THE MOTOR/TRANSAXLE ASSEMBLY� '�������������������������� ������ �����!�����������!��������������

CONSOLE, CHARGER, AND ELECTRONICS� O��������������������������� �������������������&������������� �����������������������������������������������

STORAGE����������������������������������&���������������� �������;� @��������������������������������� <������������������� =�������������������� �����%��������� :%��������������������������������&����������������&������

@����������������� ������������������%��������������������������������������������������������������'����6���������������������������������������������������%�����������������������������������������

X I . C A R E A N D M A I N T E N A N C E

�����������������������������������������;����������� ���������0���� ��������;��������"��% ���������� ���������������� �������������� ��"

Page 36: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

36 www.pridemobility.com Sonic/RevA/May 2004

X I I . W A R R A N T Y

THREE-YEAR LIMITED WARRANTY'������������������������������������9���������������� ���6 ������ ���������

'����5�������������%������������9��������������&�� ���� ������6��� @�������;�) P�������������������� =���������;�(*P�������������������� '��������;�. P�������������������

THREE-YEAR WARRANTY EXCEPTIONS*�����%��+�������������������������������������������������%�� ���������������������3'�����������������������������%������������������������%�����&�����%�����������������41���"����+'����5�������������������������������������������6��8��6���������������������������������

ONE-YEAR LIMITED WARRANTY@�����3)4����������������������� ����������������������������������������������������� ������������ �����������������������������������&������������������7������������%�����������������%�������������$�����6��������

'����������������������������������������3��&5�����������������4�'������������������������������

/���������%������������������������������������7����������%�����<����������������������������������������:������������������������������������������������������������������������������������������������������������������������

WARRANTY EXCLUSIONS� :8=������������������������%���3���������������������4� 8������3���������������������%�������&5�����������������4� '��������������3���������������������4� "�����������������3���������������������4� J���������$������������������������������������������������������������������������ ���������������������������������� <�������������;�����������������������6���9����� ������ ������� ������������9�������������5

���9����������9��������9�������������������������������� 1���� ���%�������� �������� �����������������������������������������

'�������������&�������������

���������������� ��������������������������������������������������������� �������������3)4��������������������������������������&���������������:����������������������������&�������'��������&�����%��������1�����������������!����������������������������������������&�������

=��������������������������������������������������������������������&�����������������������������������!��������������=� �����%������������&����������������������

Page 37: US Sonic '04 om PDF12 Sonic/RevA/May 2004 II. SAFETY Figure 3. Correct Curb Approach Figure 3A. Incorrect Curb Approach OUTDOOR DRIVING SURFACES B ˆ % ˚ ˚ ˇ ˆ ˆ˚ˇ %ˆ ˆ ˆ

�������������� ��������� ��������������������

�������� !"�#��$�%!