Toyota Motor Corporation Application For Certification

Toyota Motor Corporation

Application For Certification - Part 1

2016 Model Year

Durability Group: GTYXGPGNN62V

Evap. Family:

GTYXR0107R12

Test Group: GTYXV01.5FEA

Durability Group Description:

Otto Cycle, Four Stroke, Piston, Gasoline Fueled, Direct Fuel Injection, Catalyst Code: Warm-up; P544 / Underfloor; P545

Test Group Description: 1.5 Liter, I4 Engine, LDV

Applicable Standards:

Federal: Tier2 Bin5 California: LEVII-ULEV(NMOG+NOx)

Carlines Covered:

iA Yaris

Vehicles Tested:

6ECP5VS1-008 Config. 4 FTP GTKX10033475 HWY GTKX10033480 US06 GTKX10033481 SC03 GTKX10033482 Cold-FTP GTKX10033479 Evap(3day) GTKX10033476 Evap(RL) GTKX10033478 ORVR GTKX10033477

EPA Response Requested by: May 21, 2015

For Questions, Contact:

EPA: Andrea Frederick, (734) 995-2586 CARB: Mort Smith, (310) 787-5647

Initial Submission on April 1, 2015

Toyota Motor Corporation 2016 Model Year Application for Certification

INDEX

PART I1 Correspondence and Communications

1-1 Mailing Information

1-2 Responsible Official

2 Durability Group Description

2-1 Description of Durability Group determined per §86.1820-01

2-2 List of Equivalency Factors

2-3 Durability Vehicle Number and the Configuration Number

3 Evaporative/Refueling Family Description

3-1 Description of Evaporative/Refueling Family per §86.1821-01

3-2 Durability Vehicle Number and the Configuration Number

4 Durability Test Procedure Description

4-1 Description of Durability Test Procedure for Exhaust Emission

4-2 Description of Durability Test Procudure for Evaporative Emission

4-3 Description of Durability Test Procedure for Refueling Emission

4-4 List of DF

5 Test Group Description

5-1 Description of Test Group per §86.1827-01

6 Test Vehicle Description

7 Test Results and GHG CREE In-use Emission Standards Covered by Certificate

8 Statements of Compliance

9 OBD System Description and Approval Letter

10 Description of Alternate-Fueled Vehicles

11 AECD Descriptions

11-1 Control, Parameters and Justification

11-2 Parameters and Devices

12 Description of Vehicles Covered by Certificate and Test Parameters

12-1 Vehicle Parameters

12-2 Test Parameters

12-2-1 Test Procedure

12-2-2 Shift Schedules

12-2-3 Dyno Loading Information

12-2-4 Evaporative Testing Parameters

13 Projected Sales

13-1 Projected Sales

13-2 Final Sales (Final)

14 Request for Certification

15 Other Information

15-1 Engine Oil Information

15-2 Fee Filing Form

15-3 Advanced Technology Systems for CO2 and Fuel Economy Performance

15-4 Battery Performance Determination for PHEVs and EVs

15-5 Fuel Fired Heater

16 Confidential Information

17 California ARB Information

17-1 California Fill Pipe Specifications

17-2 NMOG/NMHC and HCHO/NMHC ratio

17-3 California Warranty Statement

17-4 Certification Summary Sheet

17-5 Fuel Evaporative Emission Results

17-6 Vehicle Emission Control Information Label

18 Information on Service of Process

19 Revisions

PART II （Update)

1 Part Numbers

2 Calibration Information

3 Description of Vehicles Covered by Certificate and Test Parameters

4 Final Sales (Final)

5 Service Manuals and Service Bulletins

1-P5VT-1

1. CORRESPONDENCE AND COMMUNICATION 1.1 Mailing information

Corporate name and address to appear on Certificates of Conformity/Executive Orders

Toyota Motor Corporation 1, Toyota-cho, Toyota, Aichi, 47l-8572 Japan

Person and address to whom the Certificates of Conformity should be mailed

Kevin Webber General Manager Toyota Motor Engineering & Manufacturing North America, Inc. Toyota Technical Center 1555 Woodridge Avenue Ann Arbor, Michigan 48105 U.S.A.

Person and address to whom the Executive Orders should be mailed

Daisuke Shibata Manager Vehicle Regulation and Certification Engineering Toyota Motor Engineering & Manufacturing North America, Inc. Toyota Technical Center 1630 West 186th Street Gardena, California 90248 U.S.A.

1-P5VT-2

1.2 Responsible official

Names and title of persons authorized to communicate with EPA and CARB

Toyota Motor Engineering & Manufacturing North America, Inc. Toyota Technical Center

Wataru Ozawa --- Vice President, Powertrain & Regulation

Kevin Webber --- General Manager, Vehicle Regulation & Certification Engineering Takashi Nishikiori --- General Manager, Powertrain Certification & Test Engineering

Vehicle Regulation & Certification Engineering (Ann Arbor Office)

Main Phone No. (734) 995 - 2600 Fax No. (734) 995 - 9049

Name Title Phone No. E-mail Address

Matt Kevnick Senior Principal Engineer (734) 995-3755 [email protected]

Katsuaki Suzuki** Group Coordinator (734) 995-3753 [email protected]

Thomas Beierschmitt Senior Principal Engineer (734) 995-3743 [email protected]

Andrea Frederick * Senior Engineer (734) 995-2586 [email protected]

Helenann Gabler Certification Assistant (734) 995-2420 [email protected]

Vehicle Regulation & Certification Engineering (Los Angeles Office)

Main Phone No. (310) 787 - 5500 Fax No. (310) 787 - 5655


Daisuke Shibata Manager (310) 787-5867 [email protected]

Michael Lord Executive Engineer (310) 787-5644 [email protected]

Mort Smith * Principal Engineer (310) 787-5647 [email protected]

Andrea Lubawy Engineer (310) 787-5574 [email protected]

Naomi Kruse Certification Assistant (310) 787-5510 [email protected]

Powertrain Certification & Test Engineering

Main Phone No. (734) 995 - 2600 Fax No. (734) 995 – 5971


Takashi Nishikiori General Manager (734) 995-3745 [email protected]

Julie Worster Associate (734) 995-3715 [email protected]

(*: Primary Certification Contact & **: Primary Cert Test Contact)

2-P5VT-1

2. DURABILITY GROUP DESCRIPTION 2-1. Description of Durability Group determined per §86.1820-01

Durability Group Name

Combustion Cycle

Engine Type Fuel Used Basic Fuel Metering System

Catalyst Construction

Catalyst Code *1 *2

Grouping Statistic (g/liter)

Car Line

GTYXGPGNN62V Otto cycle Four Stroke Piston

Otto Spark Water cooled

Gasoline Direct fuel Injection

Monolith (W) P544 (U) P545

1.3

iA Yaris

*1: For precious metal composition of catalyst, please refer to the Mazda Motor Corporation’s Common Section “16-1. Catalyst Information”. *2: “(W)” means “Warm-up Catalyst”. “(U)” means “Underfloor Catalyst”. 2-2. List of Equivalency Factors

DURABILITY GROUP CERTIFIED WITH MAZDA THERMAL-CHEMICAL BENCH AGING CYCLE

Durability Group Test Group Engine Program Standard Useful

Life

Equivalency Factor *1

ABC/SRC

GTYXGPGNN62V GTYXV01.5FEA 1.5L iA

Yaris

T2B5 120K*21.1

ULEV2(NMOG+NOx)150K*3/120K*2

*1: Manufacturer Aging = SRC aging time x Equivalency Factor *2: 150K DFs are used to comply with 150k and 120k emission standards. *3: 150K useful life is applied to FTP and HWY only when NMOG+NOx option is applied. 2-3. Durability Vehicle Number and the Configuration Number

Durability Group Durability Vehicle

Number Configuration

Number Durability Vehicle Model

Applicable Program

GTYXGPGNN62V 6DCP5VS1-004 0 2016MY Mazda MAZDA2 1.5L S6

iA Yaris

3-P5VT-1

3. EVAPORATIVE/REFUELING FAMILY DESCRIPTION

3-1. Description of Evaporative/Refueling Family per §86.1821-01

3-2. Durability Vehicle Number and the Configuration Number

Durability Vehicle Number Configuration Number

Durability Vehicle Model Applicable Program

6DCPES1-001 0 2016MY Mazda CX-3 2.0L S6 2WD

iA Yaris 6DCPES1-002 0

Car Line Evaporative/Refueling Family Name

iA 1.5L Yaris 1.5L

GTYXR0107R12

4-P5VT-1

4. DURABILITY TEST PROCEDURE DESCRIPTION 4-1. Description of Durability Test Procedure for Exhaust Emission Please refer to the Mazda Motor Corporation’s Common Section 16. 4-2. Description of Durability Test Procedure for Evaporative Emission Please refer to the Mazda Motor Corporation’s Common Section 16. 4-3. Description of Durability Test Procedure for Refueling Emission Please refer to the Mazda Motor Corporation’s Common Section 16. 4.4. List of DF Please refer to the Section 6 & 7 (Certification Summary Information Report) of this application document.

5-P5VT-1

5. TEST GROUP DESCRIPTION 5.1. Description of Test Group per §86.1827-01

Car Line iA Yaris

Test Group Name GTYXV01.5FEA Engine Displacements Covered 1496.1cc Arrangement and Number of Cylinders I4 Vehicle Class(es) Covered LDV Emission Standards Class Federal Tier2 Bin5 / California LEVII-ULEV * Applicable Emission Standards Please refer to section 6 & 7 of this application document.

*: This T/G complies with optional NMOG+NOx emission standard per California 2015 and Subsequent Model Criteria Pollutant Exhaust Emission Standards and Test Procedures and 2017 and Subsequent Model Greenhouse Gas Exhaust Emission Standards and Test Procedures for PCs, LDTs and MDVs, Part1, E, 1.1, 1.1.1

Manufacturer Toyota Motor Corporation Manufacturer Code TYX

Test Group GTYXV01.5FEA Evaporative/Refueling Family GTYXR0107R12

Certificate Number N/A CARB Executive Order # N/A

Certificate Issue Date N/A Certificate Revision Date N/A

Certificate Effective Date N/A Conditional Certificate --

CSI Revision # N/A CSI Submission/Revision Date 03/02/2015

Model Year 2016

Test Group Information

CSI Type Update for Correction Running Change Reference Number N/A

GHG Exempt Status Not Exempt

Drive Sources and Fuel(s)

Drive Source #1: Combustion Engine

Fuel Basic Fuel Metering System Lean Burn Strategy Indicator

Gasoline Spark Ignition Direct fuel injection N

Hybrid Indicator No

Multiple Fuel Storage -- Rechargeable Energy Storage System Indicator --

Multiple Fuel Combustion -- Off-board Charge Capable Indicator --

Fuel Cell Indicator -- EPA Vehicle Class LDV

Federal Clean Fuel Vehicle No Federal Clean Fuel Vehicle Standard --

Federal Clean Fuel Vehicle ILEV No California Partial Zero Emissions Vehicle Indicator No

Durability Group Name GTYXGPGNN62V Durability Group Equivalency Factor 1.1

Reduced Fee Test Group No Certification Region Code(s) FA, CA

Complies with HD GHG 2b/3 regulations? No

Introduction into Commerce Date -- CAP2000 Conditional Certificate? N/A

Independent Commercial Importer? -- Alternative Fuel Converter Certificate? --

SFTP Federal Composite ComplianceIdentifier Tier 2 SFTP Tier 2 Composite CO Option Yes

SFTP LEV-III Composite ComplianceIndicator No

OBD Compliance Type CARB OBD Demonstration Vehicle Test Group GTKXV01.55BB

Mfr Test Group Comments Durability group equivalency factor = ABC/SRC. This T/G complies with optional NMOG+NOx emission standard per California 2015 andSubsequent Model Criteria Pollutant Exhaust Emission Standards and Test Procedures and 2017 and Subsequent Model Greenhouse Gas ExhaustEmission Standards and Test Procedures for PCs, LDTs and MDVs, Part1, E, 1.1, 1.1.1

Mfr Exhaust / Evap Standards Comments --

Date: 03/02/2015 04:18:51 AM Certification Summary Information Report

Page 1 of 20 CSI Submission/Revision Date: 03/02/2015

6&7-P5VT-1

m071205

6&7. TEST VEHICLE DESCRIPTION & TEST RESULTS

Evaporative/Refueling Family Information

Evaporative Summary Information Type New Submission/Correction Date 02/15/2015

Integrated ORVR? Yes Fuel(s) Gasoline

Multiple Fuel Storage --

Bladder Fuel Tank? No

Fuel Tank Material Plastic Fuel Tank Material Description High Density Polyethylene

Fill Pipe Seal Type Liquid seal

Air Intake System Vapor Storage Device? No Air Intake System Vapor Storage Device Description N/A

Fuel System Vapor Storage Canister? Yes Other Vapor Storage N/A

Fuel System Vapor Storage Canister(s) TotalWorking Capacity (grams) 107 Number of Primary Canisters 1

Number of Bleed Canisters 0 Bleed Canister Total Working Capacity (grams) N/A

Mfr Evaporative/Refueling Family Comments --

Leak Family Details

Leak Family Indicator No

Canister Bleed Test Indicator No Applicability of Evaporative Canister Bleed Test --

Evaporative Canister Bleed Test Comments --

CARB Fuel Only (Rig) Test Indicator No Applicability of CARB Fuel Only (Rig) Test --

CARB Fuel Only (Rig) Test Comments --

Models Covered by this Certificate

Carline Manufacturer Division CarlineCertification Region

Code(s) Drive System Trans - Type - # of Gears Trans - Lockup

Toyota MotorCorporation 3 - SCION 60 - iA Federal 2-Wheel Drive, Front Manual 6 No

Toyota MotorCorporation 3 - SCION 60 - iA

California + CAASection 177 states 2-Wheel Drive, Front Semi-Automatic 6 Yes

Toyota MotorCorporation 1 - TOYOTA 75 - YARIS Federal 2-Wheel Drive, Front Manual 6 No

Toyota MotorCorporation 1 - TOYOTA 75 - YARIS Federal 2-Wheel Drive, Front Semi-Automatic 6 Yes

Toyota MotorCorporation 3 - SCION 60 - iA

California + CAASection 177 states 2-Wheel Drive, Front Manual 6 No

Toyota MotorCorporation 3 - SCION 60 - iA Federal 2-Wheel Drive, Front Semi-Automatic 6 Yes

Engine DescriptionHybrid Type -- Hybrid Description --

Engine Type 4-Stroke Spark Ignition Mfr Engine Description --

Engine Block Arrangement Inline Mfr Engine Block Arrangement Description --

Camless Valvetrain Indicator No Oil Viscosity/Classification GF-5 0W-20

Number of Cylinders/Rotors 4




6&7-P5VT-2

After Treatment Device(s) (ATD)ATD Number ATD Type ATD Precious Metal Substrate Material Substrate Construction

1 Three-way catalyst Paladium + Rhodium Ceramic Monolith

2 Three-way catalyst Platinum + Rhodium Ceramic Monolith

Mfr After Treatment Device (ATD)Comments --

Direct Ozone Reduction (DOR) Device Not Equipped

Mfr Emission Control Device Comments --

Engine Configuration Number 1

Engine Displacement (liters) 1.5 Engine Rated Horsepower 106

Number of Inlet Valves Per Cylinder 2 Number of Exhaust Valves Per Cylinder 2

Air Aspiration Method Naturally Aspirated Number of Air Aspiration Devices N/A

Air Aspiration Device Configuration -- Charge Air Cooler Type N/A

Cylinder Deactivation Description N/A

Variable Valve Timing System Description

This technology optimizes the valve timing byusing computer control to continuously switchthe intake valve opening/closing timingaccording to driving conditions. Variable Valve Lift System N/A

Number of Knock Sensors 1

Air/Fuel Sensor # 1 Type Heated oxygen Air/Fuel Sensor # 1 Description N/A

Air/Fuel Sensor # 2 Type Heated air fuel Air/Fuel Sensor # 2 Description N/A

Mfr Air/Fuel Sensor Comments --

Exhaust Gas Recirculation Yes EGR Type Variable Valve Timing Control

Cooled Exhaust Gas Recirculation No

Closed Loop Air Injection System No Air Injection Type --

Mfr Engine Configuration Comments --

Official Test Numbers

Test GroupFuel FTP US06 SC03 Cold CO Highway

EPA CityLitmusValue

EPA CityLitmus

Threshold

EPAHighwayLitmusValue

EPAHighwayLitmus

Threshold

CREEWeighting

Factor

Gasoline GTKX10033475 GTKX10033481 GTKX10033482 GTKX10033479 GTKX10033480 29.4 27.6 34.2 32.9 N/A




6&7-P5VT-3

Emission Data Vehicle Information

Vehicle ID / Configuration 6ECP5VS1-008 / 4

Vehicle ModelRepresented Test Vehicle Make MAZDA Represented Test Vehicle Model MAZDA2

Leak Family Details

Leak Family Identifier -- Leak Family Name --

Drive Sources and Fuel System Details

Drive Source and Fuel# Drive Source Fuel

1 Combustion Engine Gasoline

Hybrid Indicator N

Multiple Fuel Storage -- Multiple Fuel Combustion --

Fuel Cell Indicator -- Rechargeable Energy Storage System Indicator --

Rechargeable Energy Storage System -- Rechargeable Energy Storage System, if 'Other' --

Off-board charge Capable Indicator --

Transmission Type Semi-Automatic # of Transmission Gears 6

Engine Code 6P5VSAAA Axle Ratio 3.82

Displacement (liters) 1.5 Rated Horsepower 106

Equivalent Test Weight (pounds) 2750 Air Aspiration Method Naturally Aspirated

Drive Mode While Testing 2-Wheel Drive, Front SIL Usage Not eqipped

Aged Emission Components 4,000 (mi)

Dynamometer Coefficients:

Target Coefficients Set Coefficients

CoefficientCategory A (lbf) B (lbf/mph) C (lbf/mph**2) A (lbf) B (lbf/mph) C (lbf/mph**2)

EPA Calculated Total Road Load Horse Power forCity/Highway/Evap Coefficients

City/Highway/Evap 19.069 0.06928 0.018672 7.34 -0.10259 0.019406 9.2

Cold CO 21.188 0.07698 0.020747 6.772 -0.08136 0.021041 N/A

US06 19.069 0.06928 0.018672 7.34 -0.10259 0.019406 N/A

Manufacturer Test Vehicle Comments 16MY MAZDA2 1.5L ETW 2750 S6 P185/65 R15 4 EM.




6&7-P5VT-4

Test # GTKX10033475 Test Procedure 35 - California fuel 3-dayexhaust

Exhaust Test # for this Evap Test N/A Test Fuel Type 23 - CARB Phase II Gasoline

Test Date 09/08/2014 Fuel Gasoline

Vehicle Class LDV/Passenger Car DF Type Mfr. Determined

Verify Test Lab ID MIYOSHI PROVING GROUND

E10 Evaporative Test Measurement Method --

Test Results

Test Result Name Unrounded Test Result Verify Calculated FE MPG Equivalent Value

Bag 1 Carbon Dioxide 247 --

Bag 1 Fuel Economy 35.3 35.3





CH4 - Methane 0.0017 --

Carbon Monoxide 0.15 --

Drive Trace Absolute Speed Change Rating -0.11 --

Drive Trace Energy Economy Rating -1.14 --

Drive Trace Inertia Work Ratio Rating 0.1 --

Manufacturer Fuel Economy 37.4 37.4

Nitrogen Oxide 0.0104 --

Nitrous Oxide 0.01 --

Non-methane Hydrocarbon 0.0053 --

Non-methane organic gas (California) 0.0055 --

Total Hydrocarbon 0.007 --

Test Result Name Unrounded Test Result Verify Calculated CREE/OPT-CREE

Carbon-Related Exhaust Emissions 234.2572653 234

Optional Carbon-Related Exhaust Emissions 237.2745159 237

Test Result Name Unrounded Test Result Verify Calculated CO2

Carbon dioxide 234 --

Manufacturer Test Comments 16MY MAZDA2 1.5L ETW 2750 S6 P185/65 R15 4 EM. FTP




6&7-P5VT-5

CertificationRegion Useful Life Standard Level Emission Name

RoundedResult RAF

NMOG/NMHC Ratio

DieselAdjustment

Factor Add DF Mult DFCertification

Level Standard Pass/Fail

Fed 50,000 miles Federal Tier 2Bin 5

CO 0.15 -- -- -- 0.00 -- 0.2 3.4 Pass


NMOG 0.0055 -- 1.04 -- 0.0034 -- 0.009 0.075 Pass


NOX 0.010 -- -- -- 0.003 -- 0.01 0.05 Pass


CO 0.15 -- -- -- 0.00 -- 0.2 4.2 Pass


CO-COMP 0.46 -- -- -- 0.00 -- 0.5 4.2 Pass


CREE 234 -- -- -- 0 -- 234 -- --


HC-NM+NOX-COMP

0.043 -- -- -- 0.021 -- 0.04 0.65 Pass


METHANE 0.0017 -- -- -- 0.0069 -- 0.009 0.030 Pass


NMOG 0.0055 -- 1.04 -- 0.0109 -- 0.016 0.090 Pass


NOX 0.010 -- -- -- 0.010 -- 0.02 0.07 Pass


OPT-CREE 237 -- -- -- 0 -- 237 -- --

CA 120,000 miles California LEV-II ULEV125

CREE 234 -- -- -- 0 -- 234 -- --


METHANE 0.0017 -- -- -- 0.0069 -- 0.009 0.030 Pass


OPT-CREE 237 -- -- -- 0 -- 237 -- --


CO 0.15 -- -- -- 0.00 -- 0.2 2.1 Pass


NMOG 0.0055 -- 1.04 -- 0.0109 -- 0.016 99.999 Pass


NMOG+NOX 0.0159 -- 1.04 -- -- -- 0.037 0.125 Pass


NOX 0.0104 -- -- -- 0.0103 -- 0.021 99.999 Pass

NOTE: For Non-charge depleting tests, the Rounded Result for CREE/OPT-CREE Emission names are Verify-calculated values.




6&7-P5VT-6

Test # GTKX10033479 Test Procedure 11 - Cold COExhaust Test # for this Evap Test N/A Test Fuel Type 26 - Cold CO Regular (Tier 2)





Test Results







Bag 3 Fuel Economy 37 37

CH4 - Methane 0.0079 --


Drive Trace Absolute Speed Change Rating 0.24 --










Manufacturer Test Comments 16MY MAZDA2 1.5L ETW 2750 S6 P185/65 R15 4 EM. COLDCO


RoundedResult RAF

NMOG/NMHC Ratio

DieselAdjustment




CO 0.33 -- -- -- 0.00 -- 0.3 10.0 Pass


HC-NM 0.13 -- -- -- 0.01 -- 0.1 0.3 Pass


CO 0.33 -- -- -- 0.00 -- 0.3 10.0 Pass


HC-NM 0.13 -- -- -- 0.01 -- 0.1 0.3 Pass




6&7-P5VT-7

Test # GTKX10033480 Test Procedure 3 - HWFEExhaust Test # for this Evap Test N/A Test Fuel Type 23 - CARB Phase II Gasoline





Test Results


CH4 - Methane 0.0007 --







Nitrous Oxide 0.01 --




Test Result Name Unrounded Test Result Verify Calculated CREE/OPT-CREE

Carbon-Related Exhaust Emissions 179.0375958 179

Optional Carbon-Related Exhaust Emissions 182.0332431 182



Manufacturer Test Comments 16MY MAZDA2 1.5L ETW 2750 S6 P185/65 R15 4 EM. HWY




6&7-P5VT-8


RoundedResult RAF

NMOG/NMHC Ratio

DieselAdjustment




NOX 0.002 -- -- -- 0.003 -- 0.00 0.07 Pass


CREE 179 -- -- -- 0 -- 179 -- --


NOX 0.002 -- -- -- 0.010 -- 0.01 0.09 Pass


OPT-CREE 182 -- -- -- 0 -- 182 -- --


CREE 179 -- -- -- 0 -- 179 -- --


OPT-CREE 182 -- -- -- 0 -- 182 -- --


NMOG 0.0015 -- 1.04 -- 0.0109 -- 0.012 99.999 Pass


NMOG+NOX 0.0037 -- 1.04 -- -- -- 0.025 0.125 Pass


NOX 0.0022 -- -- -- 0.0103 -- 0.012 99.999 Pass

NOTE: For Non-charge depleting tests, the Rounded Result for CREE/OPT-CREE Emission names are Verify-calculated values.

Test # GTKX10033476 Test Procedure 38 - CA fuel 3-day evap.Exhaust Test # for this Evap Test GTKX10033475 Test Fuel Type 23 - CARB Phase II Gasoline


Vehicle Class N/A DF Type Mfr. Determined



Test Results



Manufacturer Test Comments 16MY MAZDA2 1.5L ETW 2750 S6 P185/65R15 4 3Day-Evap EM.

CertificationRegion Useful Life Standard Level Emission Name Rounded Result Add DF Certification Level Standard Pass/Fail

Fed 120,000 miles Federal LEV-II Evap HC-TOTAL 0.244 0.012 0.26 0.50 Pass

CA 150,000 miles California LEV-IIEvap

HC-TOTAL 0.244 0.012 0.26 0.50 Pass




6&7-P5VT-9

Test # GTKX10033477 Test Procedure 24 - Federal fuel refueling test(ORVR)

Exhaust Test # for this Evap Test GTKX10033475 Test Fuel Type 61 - Tier 2 Cert Gasoline





Test Results


Hydrocarbon for Running Loss and ORVR 0.018 --

Manufacturer Test Comments 16MY MAZDA2 1.5L ETW 2750 S6 P185/65R15 4 ORVR EM.


Fed 120,000 miles Federal LEV-II Evap HC 0.018 0.000 0.02 0.20 Pass


HC 0.018 0.000 0.02 0.20 Pass

Test # GTKX10033478 Test Procedure 37 - California Fuel RunningLoss

Exhaust Test # for this Evap Test GTKX10033475 Test Fuel Type 23 - CARB Phase II Gasoline





Test Results


Hydrocarbon for Running Loss and ORVR 0 --

Manufacturer Test Comments 16MY MAZDA2 1.5L ETW 2750 S6 P185/65 R15 4 Running Loss EM


Fed 120,000 miles Federal LEV-II Evap HC 0.000 0.000 0.00 0.05 Pass


HC 0.000 0.000 0.00 0.05 Pass




6&7-P5VT-10

Test # GTKX10033481 Test Procedure 90 - US06Exhaust Test # for this Evap Test N/A Test Fuel Type 23 - CARB Phase II Gasoline





Test Results






CH4 - Methane 0.0062 --









SFTP Non-methane Hydrocarbon + NitrogenOxides for US06 or SC03 0.025 --




Manufacturer Test Comments 16MY MAZDA2 1.5L ETW 2750 S6 P185/65 R15 4 EM. US06


RoundedResult RAF

NMOG/NMHC Ratio

DieselAdjustment




CO 1.22 -- -- -- -- -- 1.2 8.0 Pass


HC-NM+NOX 0.025 -- -- -- -- -- 0.02 0.14 Pass


CO 1.22 -- -- -- -- -- 1.2 8.0 Pass


HC-NM+NOX 0.025 -- -- -- -- -- 0.02 0.14 Pass




6&7-P5VT-11

Test # GTKX10033482 Test Procedure 95 - SC03Exhaust Test # for this Evap Test N/A Test Fuel Type 23 - CARB Phase II Gasoline



Verify Test Lab ID ETL-4 (Hiroshima)


Test Results


CH4 - Methane 0.0061 --



Drive Trace Energy Economy Rating 1.75 --






SFTP Non-methane Hydrocarbon + NitrogenOxides for US06 or SC03 0.026 --




Manufacturer Test Comments 16MY MAZDA2 1.5L ETW 2750 S6 P185/65 R15 4 EM. SC03


RoundedResult RAF

NMOG/NMHC Ratio

DieselAdjustment




CO 0.17 -- -- -- -- -- 0.2 2.7 Pass


HC-NM+NOX 0.026 -- -- -- -- -- 0.03 0.20 Pass


CO 0.17 -- -- -- -- -- 0.2 2.7 Pass


HC-NM+NOX 0.026 -- -- -- -- -- 0.03 0.20 Pass




6&7-P5VT-12

Consolidated List of StandardsExhaust Standards

Cert Region California + CAA Section 177 states Cert/In-Use Code Both

Vehicle Class LDV/Passenger Car Standard Level California LEV-II ULEV125

Fuel Gasoline Test Procedure California fuel 3-day exhaust

Useful Life Emission NameRounded

Result RAFNMOG /NMHC

Upward DieselAdjustment

Factor

DownwardDiesel

AdjustmentFactor Mult DF Add DF Std

120,000 miles CREE -- -- -- -- -- -- 0 999.9999

120,000 miles METHANE -- -- -- -- -- -- 0.0069 0.030

120,000 miles OPT-CREE -- -- -- -- -- -- 0 999.9999

150,000 miles CO -- -- -- -- -- -- 0.00 2.1

150,000 miles NMOG -- -- 1.04 -- -- -- 0.0109 99.999

150,000 miles NMOG+NOX -- -- 1.04 -- -- -- 0 0.125

150,000 miles NOX -- -- -- -- -- -- 0.0103 99.999

Cert Region Federal Cert/In-Use Code Both

Vehicle Class LDV/Passenger Car Standard Level Federal Tier 2 Bin 5

Fuel Gasoline Test Procedure US06




Factor

DownwardDiesel


4,000 miles CO -- -- -- -- -- -- -- 8.0

4,000 miles HC-NM+NOX -- -- -- -- -- -- -- 0.14



Fuel Gasoline Test Procedure HWFE




Factor

DownwardDiesel


50,000 miles NOX -- -- -- -- -- -- 0.003 0.07

120,000 miles CREE -- -- -- -- -- -- 0 999.9999

120,000 miles NOX -- -- -- -- -- -- 0.010 0.09

120,000 miles OPT-CREE -- -- -- -- -- -- 0 999.9999




6&7-P5VT-13



Fuel Gasoline Test Procedure California fuel 3-day exhaust




Factor

DownwardDiesel


50,000 miles CO -- -- -- -- -- -- 0.00 3.4

50,000 miles NMOG -- -- 1.04 -- -- -- 0.0034 0.075

50,000 miles NOX -- -- -- -- -- -- 0.003 0.05

120,000 miles CO -- -- -- -- -- -- 0.00 4.2

120,000 miles CO-COMP -- -- -- -- -- -- 0.00 4.2

120,000 miles CREE -- -- -- -- -- -- 0 999.9999

120,000 miles HC-NM+NOX-COMP -- -- -- -- -- -- 0.021 0.65

120,000 miles METHANE -- -- -- -- -- -- 0.0069 0.030

120,000 miles NMOG -- -- 1.04 -- -- -- 0.0109 0.090

120,000 miles NOX -- -- -- -- -- -- 0.010 0.07

120,000 miles OPT-CREE -- -- -- -- -- -- 0 999.9999



Fuel Gasoline Test Procedure HWFE




Factor

DownwardDiesel


120,000 miles CREE -- -- -- -- -- -- 0 999.9999

120,000 miles OPT-CREE -- -- -- -- -- -- 0 999.9999

150,000 miles NMOG -- -- 1.04 -- -- -- 0.0109 99.999

150,000 miles NMOG+NOX -- -- 1.04 -- -- -- 0 0.125

150,000 miles NOX -- -- -- -- -- -- 0.0103 99.999



Fuel Gasoline Test Procedure SC03




Factor

DownwardDiesel


4,000 miles CO -- -- -- -- -- -- -- 2.7

4,000 miles HC-NM+NOX -- -- -- -- -- -- -- 0.20




6&7-P5VT-14



Fuel Gasoline Test Procedure US06




Factor

DownwardDiesel


4,000 miles CO -- -- -- -- -- -- -- 8.0

4,000 miles HC-NM+NOX -- -- -- -- -- -- -- 0.14



Fuel Gasoline Test Procedure Cold CO




Factor

DownwardDiesel


50,000 miles CO -- -- -- -- -- -- 0.00 10.0

120,000 miles HC-NM -- -- -- -- -- -- 0.01 0.3



Fuel Gasoline Test Procedure Cold CO




Factor

DownwardDiesel


50,000 miles CO -- -- -- -- -- -- 0.00 10.0

120,000 miles HC-NM -- -- -- -- -- -- 0.01 0.3



Fuel Gasoline Test Procedure SC03




Factor

DownwardDiesel


4,000 miles CO -- -- -- -- -- -- -- 2.7

4,000 miles HC-NM+NOX -- -- -- -- -- -- -- 0.20




6&7-P5VT-15

Evaporative/Refueling Standards

Evaporative/Refueling Family GTYXR0107R12 Cert Region California + CAA Section 177 states

Cert/In-Use Code Both Standard Level California LEV-II Evap

Test Procedure CA fuel 3-day evap.

Fuel Useful Life Emission Name Rounded Result Std Add DF

Gasoline 150,000 miles HC-TOTAL -- 0.50 0.012



Test Procedure California Fuel Running Loss


Gasoline 150,000 miles HC -- 0.05 0.000

Evaporative/Refueling Family GTYXR0107R12 Cert Region Federal

Cert/In-Use Code Both Standard Level Federal LEV-II Evap

Test Procedure CA fuel 3-day evap.


Gasoline 120,000 miles HC-TOTAL -- 0.50 0.012



Test Procedure Federal fuel refueling test (ORVR)





Test Procedure California Fuel Running Loss






6&7-P5VT-16



Test Procedure Federal fuel refueling test (ORVR)






6&7-P5VT-17

GlossaryUseful Life

4 4,000 miles 120 120,000 miles

50 50,000 miles 150 150,000 miles

100 100,000 miles

Emission Name

HC-TOTAL Total Hydrocarbon METHANOL CH3OH - Methanol

CO Carbon Monoxide N2O Nitrous Oxide

CO2 Carbon dioxide SPITBACK Spitback Hydrocarbon in grams

CREE Carbon-Related Exhaust Emissions AMP-HRS Integrated Amp-hours

OPT-CREE Optional Carbon-Related Exhaust Emissions START-SOC System Start State of Charge Watt-hours

NOX Nitrogen Oxide END-SOC System End State of Charge Watt-hours

PM Particulate Matter ACT-DISTANCE Actual Distance Driven (miles)

PM-COMP SFTP Composite Particulate Matter AS-VOLT Average System Voltage

HC-NM Non-methane Hydrocarbon CO2 BAG 1 Bag 1 Carbon Dioxide

OMHCE Organic material Hydrocarbon Equivalent CO2 BAG 2 Bag 2 Carbon Dioxide

OMNMHCE Organic material non-methane HC equivalent CO2 BAG 3 Bag 3 Carbon Dioxide

NMOG Non-methane organic gas (California) CO2 BAG 4 Bag 4 Carbon Dioxide

HCHO Formaldehyde NMOG+NOX Non-methane organic gases plus Nitrogen Oxides

H3C2HO Acetaldehyde NMOG+NOX-COMP SFTP Composite Non-methane Organic Gases + Nitrogen Oxides

HC-NM+NOX SFTP Non-methane Hydrocarbon + Nitrogen Oxides for US06 or SC03 DT-IWRR Drive Trace Inertia Work Ratio Rating

HC-NM+NOX-COMP SFTP Composite Non-methane Hydrocarbon + Nitrogen Oxides DT-ASCR Drive Trace Absolute Speed Change Rating

CO-COMP SFTP Composite Carbon Monoxide DT-EER Drive Trace Energy Economy Rating

ETHANOL C2H5OH - Ethanol COMB-CREE Combined Carbon-Related Exhaust Emissions

FE BAG 1 Bag 1 Fuel Economy COMB-OPT-CREE Combined Optional Carbon-Related Exhaust Emissions

FE BAG 2 Bag 2 Fuel Economy HC-TOTAL-EQUIV Total Hydrocarbon equivalent - Evap only

FE BAG 3 Bag 3 Fuel Economy METHANE-COMB Combined CH4 for HD 2b/3 vehicles only

FE BAG 4 Bag 4 Fuel Economy N2O-COMB Combined Nitrous Oxide for HD 2b/3 vehicles only

MFR FE Manufacturer Fuel Economy LEAK-DIA Effective Leak Diameter (inches)

HC Hydrocarbon for Running Loss and ORVR LEAK-GAS CAP Gas Cap Leakage (cc/min)

METHANE CH4 - Methane

Certification Region

CA California + CAA Section 177 states FA Federal

Exhaust Emission Standard Level

B1 Federal Tier 2 Bin 1 L3ULEV340 California LEV-III ULEV340



B4 Federal Tier 2 Bin 4 L3SULEV170 California LEV-III SULEV170





6&7-P5VT-18

B6 Federal Tier 2 Bin 6 L3LEV630 California LEV-III LEV630






HDV1 HDV1 (Federal HD chassis Class 2b GVW 8501-10000) T3B160 Federal Tier 3 Bin 160

HDV2 HDV2 (Federal HD chassis Class 3 GVW 10001-14000) T3B125 Federal Tier 3 Bin 125

L2 California LEV-II LEV T3B110 Federal Tier 3 Transitional Bin 110

L2OP California LEV-II LEV Optional T3B85 Federal Tier 3 Transitional Bin 85

U2 California LEV-II ULEV T3SULEV30 Federal Tier 3 Transitional LEV-II SULEV30 Carryover

S2 California LEV-II SULEV T3B70 Federal Tier 3 Bin 70

ZEV California ZEV T3B50 Federal Tier 3 Bin 50

OT Other T3B30 Federal Tier 3 Bin 30

T1 Federal Tier 1 T3B20 Federal Tier 3 Bin 20

PZEV California PZEV T3B0 Federal Tier 3 Bin 0

L2LEV160 California LEV-II LEV160 HDV2B395 Federal Tier 3 HD Class 2b Transitional Bin 395

L2ULEV125 California LEV-II ULEV125 HDV2B340 Federal Tier 3 HD Class 2b Transitional Bin 340

L2SULEV30 California LEV-II SULEV30 HDV2B250 Federal Tier 3 HD Class 2b Bin 250

L2LEV395 California LEV-II LEV395 HDV2B200 Federal Tier 3 HD Class 2b Bin 200

L2ULEV340 California LEV-II ULEV340 HDV2B170 Federal Tier 3 HD Class 2b Bin 170

L2LEV630 California LEV-II LEV630 HDV2B150 Federal Tier 3 HD Class 2b Bin 150

L2ULEV570 California LEV-II ULEV570 HDV2B0 Federal Tier 3 HD Class 2b Bin 0

L3LEV160 California LEV-III LEV160 HDV3B630 Federal Tier 3 HD Class 3 Transitional Bin 630

L3ULEV125 California LEV-III ULEV125 HDV3B570 Federal Tier 3 HD Class 3 Transitional Bin 570

L3ULEV70 California LEV-III ULEV70 HDV3B400 Federal Tier 3 HD Class 3 Bin 400

L3ULEV50 California LEV-III ULEV50 HDV3B270 Federal Tier 3 HD Class 3 Bin 270

L3SULEV30 California LEV-III SULEV30 HDV3B230 Federal Tier 3 HD Class 3 Bin 230

L3SULEV20 California LEV-III SULEV20 HDV3B200 Federal Tier 3 HD Class 3 Bin 200

L3LEV395 California LEV-III LEV395 HDV3B0 Federal Tier 3 HD Class 3 Bin 0

Transmission Type Code

AMS Automated Manual- Selectable (e.g. Automated Manual with paddles) M Manual

A Automatic OT Other

AM Automated Manual SA Semi-Automatic

CVT Continuously Variable SCV Selectable Continuously Variable (e.g. CVT with paddles)

Drive System Code

4 4-Wheel Drive P Part-time 4-Wheel Drive

F 2-Wheel Drive, Front A All Wheel Drive

R 2-Wheel Drive, Rear




6&7-P5VT-19

Additional Terms and Acronyms

AFC Alternative Fuel Converter ICI Independent Commercial Importer

CSI Certificate Summary Information ORVR Onboard Refueling Vapor Recovery

DF Deterioration Factor SIL Shift Indicator Light

Evap Evaporation, Evaporative Trans Transmission




6&7-P5VT-20

Total Datasets Submitted: 1 Accepted Datasets: 1 Rejected Datasets: 0

The original datasets are listed below. In addition, any information generated by the Verify system is also included. For any rejected datasets, the reason(s) the dataset was rejected is provided below in the Transaction Report for that particular dataset.

Verify Processing Report

Test Vehicle Information Submission

Information Process Code : N EPA Manufacturer Code : TKX Vehicle Identification Text : 6DCP5VS1-004 Vehicle Configuration Number : 0

Test Vehicle Information Details

Test Drive Code : F Shift Indicator Light Usage Identifier : 1 Aged Component Usage Identifier : 150

Engine Code Text : 6P5VSAAA Engine Rated Horsepower Value : 106 Engine Displacement Value : 1.5

Vehicle Configuration Details

Manufacturer Vehicle Configuration Number : 0 Test Group Name : GTKXV01.55BB Evaporative Refueling Family Name : GTKXR0107GBK Model Year : 2016 Actual Test Vehicle Make Text : MAZDA Actual Test Vehicle Model Text : MAZDA2

Vehicle Description Details

Drive Source Identifier : C Fuel Identifier : G

Drive Source Details

Correction Initial Value : 0.0 Correction Factor Value : 0.976 Correction Sign Identifier : - Correction Units Code : M

Odometer Correction Details

1/2 ページVerify Processing Report

2015/03/11https://cdxnodengn.epa.gov/verify/status/download.do?documentName=SubmissionProce...

Vehicle Information for Durability Vehicles 6&7-P5VT-21

m991662

長方形

m991662

長方形

m991662

長方形

Charge Air Cooler Identifier : N

Manufacturer Comment Text : 16MY MAZDA2 1.5L ETW 2750 S6 P185/65 R15 0 Exh DF.

Air Aspiration Method Identifier : NA Air Aspiration Details

Curb Weight Value : 2440 Equivalent Test Weight Value : 2750 Gross Vehicle Weight Rating Value : 3393 NV Ratio Value : 32.2 Axle Ratio Value : 3.82

Vehicle Specifications Details

Light Duty Transmission Type Identifier : SA Transmission Lockup Indicator : Y Transmission Creeper Gear Indicator : N Transmission Gear Count : 6

Transmission Specifications Details

Test Procedure Dynamometer Coefficients Category : C-H-E Target CoefficientA Value : 20.228 Target CoefficientB Value : 0.12335 Target CoefficientC Value : 0.018638 Set CoefficientA Value : 7.264 Set CoefficientB Value : 0.00887 Set CoefficientC Value : 0.018758

Target Set Coefficient Details

Original Receipt Date : 20150305 Hybrid Vehicle Indicator : N Adjusted Loaded Vehicle Weight Value : 2916 Loaded Vehicle Weight Value : 2740 Total Road Load Horsepower Value : 9.7

EPA Generated Test Vehicle Details

Transaction Status Identifier : ACCEPTED Transaction Status Details




m991662

長方形

m991662

長方形





Information Process Code : N EPA Manufacturer Code : TKX Vehicle Identification Text : 6DCPES1-001 Vehicle Configuration Number : 0



Engine Code Text : 6PESAAA Engine Rated Horsepower Value : 146 Engine Displacement Value : 2.0


Manufacturer Vehicle Configuration Number : 0 Test Group Name : GTKXV02.55NM Evaporative Refueling Family Name : GTKXR0107GBK Model Year : 2016 Actual Test Vehicle Make Text : MAZDA Actual Test Vehicle Model Text : CX-3









m991662

長方形

m991662

長方形


Manufacturer Comment Text : 16MY CX-3 2.0L 2WD ETW 3125 S6 Evap DF 001.














m991662

長方形

m991662

長方形





Information Process Code : N EPA Manufacturer Code : TKX Vehicle Identification Text : 6DCPES1-002 Vehicle Configuration Number : 0



Engine Code Text : 6PESAAA Engine Rated Horsepower Value : 146 Engine Displacement Value : 2.0


Manufacturer Vehicle Configuration Number : 0 Test Group Name : GTKXV02.55NM Evaporative Refueling Family Name : GTKXR0107GBK Model Year : 2016 Actual Test Vehicle Make Text : MAZDA Actual Test Vehicle Model Text : CX-3









m991662

長方形

m991662

長方形

m991662

長方形


Manufacturer Comment Text : 16MY CX-3 2.0L 2WD ETW 3125 S6 Evap DF 002. "Set Coefficients" described above are for 4k mile test point. For 150k mile test point, A=12.945, B=-0.02268 and C=0.026928 were used.














m991662

長方形

m991662

長方形

6&7-P5VT-27

GHG CREE In-use Emission Standards

Carline Engine Transmission Engine Code

ETW Tire Size CREE IN-USE

CREE STD

iA Yaris

1.5L

M6 w/ SIL 6P5V3AAB 2750

P185/65 R15 189.4 208 P185/60 R16 186.4 205

S6 6P5VSAAA 2750 P185/65 R15 175.4 193 P185/60 R16 178.9 197

8-P5VT-1

8. STATEMENTS OF COMPLIANCE

Please refer to the Mazda Motor Corporation’s Common Section 8.

9-P5VT-1

9. OBD SYSTEM DESCRIPTION AND APPROVAL LETTER Please refer to the Mazda Motor Corporation’s Common Section 16.

10-P5VT-1

10. DESCRIPTION OF ALTERNATE-FUELED VEHICLES Not Applicable

11-P5VT-1

11. AECD DESCRIPTIONS 11.1. Control, Parameters and Justification Please refer to section 16 of the Mazda2 test group(GTKXV01.55BB) application document. 11.2. Parameters and Devices Please refer to section 16 of the Mazda2 test group(GTKXV01.55BB) application document.

12-P5VT-1

12. DESCRIPTION OF VEHICLES COVERED BY CERTIFICATE AND TEST PARAMETERS 12.1. Vehicle Parameters

Carline iA Yaris

Model Name iA Yaris

Vehicle Classification LDV Emission Control System TWC/WU-TWC/HO2S/WR-HO2S/DFI

Engine Code 6P5V3AAB 6P5VSAAA

Number of Valves per Cylinder 4 Engine Displacement (cc) 1496.1

Sales Area Federal / California Transmission M6 S6 With Drive Selection

Overdrive Yes Regenerative Braking System Not Applicable

Grill Shutter Not Applicable SIL Applicable Not Applicable

Tire Size P185/65 R15 P185/60 R16 P185/65 R15 P185/60 R16 N/V Ratio 37.6 37.1 32.2 31.8 ETW (lbs) 2750 CW (lbs) 2385 / 2410*1 2416 / 2440*1

GVW (lbs) 3344 3393 Fuel Tank Volume (liter) 44.0

Canister Working Capacity (g) 107 Canister Bed Volume 683g (1950cc)

Power (hp) / rpm 106/6000 Torque (lb-ft) / rpm 103/4000

*1: for Canada

12-P5VT-2 12-2. Test Parameters 12-2-1. Test Procedure 12-2-1(i) Engine Starting/Stopping Procedure A. Recommendation to the Ultimate Purchaser Refer to the Owner’s Manual. B. Recommendation for FTP Based on recommendation to ultimate purchaser and 40 CFR §86.136-90, the starting procedure for FTP is provided as follows:

BEFORE STARTING THE ENGINE: 1. Fasten seat belts. 2. Make sure the parking brake is applied.

(Applicable to front-wheel drive vehicles only. For rear-wheel drive vehicles, please skip to 3.) 3. Manual Transmission – Depress the clutch pedal fully and shift the transmission select lever into

NEUTRAL. Hold the clutch pedal depressed while cranking the engine. Automatic Transmission – Place the transmission select lever in P (Park) or N (Neutral) and depress the brake pedal. Hold the brake pedal depressed while cranking the engine.

TIPS ON STARTING: 1. Turn the ignition key to the “START” position and hold it until the engine starts (a maximum of 10

seconds). Then release the ignition key. 2. After 15 seconds from engine starting, place the transaxle select lever in gear. 3. After 20 seconds from engine starting, start to run.

TIPS ON STARTING for vehicles equipped with Push Start Button: 1. Push the “Start Stop Engine” Button Once to start the engine (One push = Ignition ON & Engine

Start) (The starter stops automatically either when engine is started or after 15 seconds of cranking without engine start)

2. After 15 seconds from engine starting, place the transaxle select lever in gear. 3. After 20 seconds from engine starting, start to run. NOTE: Whether the engine is warm or cold, it should be started without first depressing of the accelerator pedal.

TIPS ON STOPPING for vehicles equipped Push Start Button: 1. Push the “Start Stop Engine” Button Once to stop the engine and to enter the accessory mode. 2. Push the “Start Stop Engine” Button Once again without pressing clutch/brake pedal to completely

shut down the engine.0L

12-P5VT-3 C. Recommendation for deactivation procedure of Traction Control System (TCS) or Dynamic Stability Control

(DSC) (Only vehicle with TCS or DSC)

In order to prevent activation of TSC/DSC during testing, either of following procedures needs to be followed: Procedure 1: Pull the ABS fuse out according to manufacturer’s separate instruction followed in Mazda’s certification testing. For IUVP Test or Surveillance Test at EPA Procedure 1 is recommended for iA and Yaris 1.5L Please contact Mazda for the instruction. Procedure 2 is recommended for MAZDA3 2.0L & 2.5L. Please contact Mazda for the instruction. For Certification Test at EPA Procedure 1 is recommended for iA and Yaris 1.5L. Fuse for the certification vehicle will be pulled out by Mazda. 12-2-1(ii) Canister Loading Procedure In order to avoid interfering with canister loading from OBD evaporative system monitoring, a canister must be loaded at least 60 minutes after engine key off. 12-2-1(iii) Vehicle preparation A vehicle must run FTP driving cycle from cold start after soaking the vehicle for more than 6 hours with ambient temperature 68°F to 86°F in order to ensure the long fuel trim learning to be operated properly. 12-2-1(iv) Drive Selection Please use the sports mode during all the emission tests. After engine starting, press the drive selection switch in the center console and make sure the indicator light (SPORT) illuminates in the speed meter. Please note that the sports mode will be turned off automatically when the ignition switch is turned off. Location of drive selection switch:

12-P5VT-4 12-2-2. Shift Schedules

1-2 2-3 3-4 4-5 5-6 1-2 2-3 3-4 4-5 5-6

17.2 27.2 36.6 46.7 54.7 10.7 19.3 30.1 38.6 50.9CTYHWYSC03

100520064004

14.7 26.4 36.8 46.4 49.3 7.8 18.4 29.8 38.7 43.2 US06 3002

For Acceleration (mph) For Cruising (mph)Schedule No.

iAYaris(1.5L)

M6 - FE

Model T/MShift T/M

Mode

CertificationTest

Purpose(*1)

*1: “FE” means “for fuel economy test”. 12-2-3. Dyno Loading Information

Model Name T/M Tire Size ETW (lbs)

Target Dynamometer Loading Coefficient

a (lbf) b (lbf/mph) c (lbf/(mph)2)

iA Yaris 1.5L

M6 P185/65 R15 2750 18.423 0.24828 0.017259

P185/60 R16 2750 18.163 0.24059 0.017206

S6 P185/65 R15 2750 19.069 0.06928 0.018672

P185/60 R16 2750 17.664 0.06869 0.018572

12-P5VT-5 12-2-4. Evaporative Testing Parameters Model Name: iA / Yaris (1.5L) Fuel Tank Temperature Profile (FTTP) and Pressure Profile (Environmental Chamber) Test Vehicle: Mazda MAZDA2 1.5L, AT Ambient Temperature: 100.0 ºF at initiation, 100.0ºF at completion Track Surface Temperature: 139.5ºF at initiation, 139.3 ºF at completion Wind Speed: Proportional Vehicle Speed Fan Sun Road Sensor: 800W/m2

13-P5VT-1 13. PROJECTED SALES 13-1. Projected Sales Refer to the Toyota Motor Corporation’s Common Section. 13-2. Final Sales (Final) Refer to the Toyota Motor Corporation’s final submission of the Common Section.

14-P5VT-1

14. REQUEST FOR CERTIFICATION

Request for Certificate

Test Group: GTYXV01.5FEA

Evaporative/Refueling Family: GTYXR0107R12

Toyota Motor Corporation requests that EPA issue a 2016 model year certificate of conformity for the above specified test group and evaporative/refueling family combination more fully described in this application. This is a 50 States test group request. This combination complies with the following application emission standards:

Federal: low altitude X high altitude X

California: X This combination meets all certification requirements, and the application is current as of the 1st day of April, 2015.

Kevin Webber General Manager Toyota Technical Center U.S.A. Inc.

15-P5VT-1

15. OTHER INFORMATION 15-1. Engine Oil Information Engine Oil Model Test Group Emission Standard

GF-5 0W-20 iA (1.5L) Yaris (1.5L)

GTYXV01.5FEAFederal Tier2-Bin5/ California LEVII-ULEV(NMOG+NOx)

15-2. Fee Filing Form Please refer to the next page. 15-3. Advanced Technology Systems for CO2 and Fuel Economy Performance Not Applicable 15-4. Battery Performance Determination for PHEVs and EVs Not Applicable 15-5. Fuel Fired Heater Not Applicable

15-P5VT-2

16-P5VT-1

16. CONFIDENTIAL INFORMATION Please refer to section 16 of the Mazda’s common section and the Mazda2 test group(GTKXV01.55BB) application document.

17-P5VT-1

17. CALIFORNIA ARB INFORMATION 17-1. California Fill Pipe Specifications

AIR RESOURCES BOARD APPLICATION FORMAT

FOR COMPLIANCE WITH THE FILL PIPE REQUIREMENTS

Manufacturer Toyota Motor Corporation Test Group GTYXV01.5FEA Vehicle Model(s) iA

Yaris (use extra sheets if required) The nomenclature and symbols used below are the same as those defined in "Specifications for Fill Pipes and Openings of Motor Vehicle Fuel Tanks", amended December 7, 1982.

ARB Specification

Manufacturer Specification*

General Specification (1) Angle in degrees

-10° 20°

-2.6° -4.1°

(2) Spill Prevention in degrees (angle between centerline of test spot in its resting

position and the horizontal plane).

30° (MIN) 32.2°

(3) Test nozzle penetration of restrictor 2.25 CM (MIN) 3.46 CM (4) Angle in degrees none 0.1 ° Fill Pipe Specification (1) Fill pipe face surface in TIR. 0.025 CM (MAX) 0.025 CM (2) Fill pipe face outside diameter. 5.75 CM (MAX) 4.99 CM (3) Internal locking lip in degrees of the inside circumference 100° (MIN)

275 °

(a) degrees extending each side of reference 35° (MIN) LS** 80.7 ° plane. each side RS** 182 °

(4) Height of lip measured from fill pipe inside wall; 0.25 CM (MIN) 0.28 CM or height of lip measured from fill pipe outside wall for outside

wall for outside diameters between 5.20 and 5.75 CM.

0.85 CM (MIN)

(5) Depth of lip (D) in centimeters 0.4 D 1.3 0.92 D 1.0

Offset Offset A none 0.41 CM Offset B none 0 CM

* dimension should include adverse tolerance condition **LS = Left side of reference plane **RS = Right side of reference plane

17-P5VT-2

17-2. NMOG/NMHC and HCHO/NMHC Ratio NMOG / NMHC = 1.04 17-3. California Warranty Statement This information is a draft. This will be updated at either Update or Final submission as it becomes finalized.

CALIFORNIA EMISSION CONTROL WARRANTY (for Scion)

Your Warranty Rights and Obligations The California Air Resources Board (CARB) and Scion are pleased to explain the emission control system warranty for your 2015 vehicle. In California, new motor vehicles must be designed, built and equipped to meet the state’s stringent anti-smog standards. CARB regulations require that Scion must warrant the emission control system on your vehicle for the time periods indicated on this page, provided there has been no abuse, neglect or improper maintenance of your vehicle. Your emission control system may include parts such as the fuel injection system, ignition system, catalytic converter and engine computer. Also included may be hoses, belts, connectors and other emissions-related assemblies. Where a warrantable condition exists, Scion will repair your vehicle at no cost to you, including diagnosis, parts and labor.

Manufacturer’s Warranty Coverage 1) For three years or 50,000 miles, whichever occurs first:

If your vehicle fails a smog-check test, all necessary repairs and adjustments will be made by Scion to ensure that your vehicle passes the test. This is your Emission Control System PERFORMANCE WARRANTY.

If any emissions-related part on your vehicle is defective, the part will be repaired or replaced by Scion. This is your SHORT-TERM Emission Control System DEFECT WARRANTY. Covered parts are listed on pages xx-xx. Specific components may have longer coverage under the terms of the Powertrain Warranty.

2) For seven years or 70,000 miles, whichever occurs first:

If an emissions-related part listed on page xx-xx is defective, the part will be repaired or replaced by Scion. This is your LONG-TERM Emission Control System DEFECT WARRANTY.

17-P5VT-3

Owner’s Warranty Responsibilities

You are responsible for performance of the required maintenance indicated in the Owner’s Manual and this booklet. Scion recommends that you retain all receipts covering maintenance on your vehicle, but Scion cannot deny warranty coverage solely for the lack of receipts or your failure to ensure the performance of all scheduled maintenance. You are responsible for presenting your vehicle to an Authorized Servicing Dealership as soon as a problem exists. The warranty repairs should be completed in a reasonable amount of time, not to exceed 30 days. You should also be aware that Scion may deny you warranty coverage if your vehicle or a part has failed due to abuse, neglect, improper maintenance or unapproved modifications. If you have any questions regarding your warranty rights and responsibilities, you should contact Scion Customer Experience at (866)70-SCION, or (866)707-2466. You may also contact the California Air Resources Board, Mobile Source Control Division, at 9528 Telstar Avenue, P.O. Box 8001, El Monte, CA 91734-8001.

What Is Not Covered These warranty obligations do not apply to failures or noncompliance caused by: The use of replacement parts not certified in accordance with aftermarket parts certification

regulations. The use of replacement parts not equivalent in quality or design to original equipment

parts. Provisions under the “What Is Not Covered” section of the New Vehicle Limited Warranty also apply to this warranty.

17-P5VT-4

Maintenance

You are responsible for performance of the required maintenance indicated in the Owner’s Manual and this booklet. Scion will not deny a warranty claim solely because you do not have records to show that you maintained your vehicle. However, any failure or noncompliance caused by lack of maintenance is not covered by this warranty. When maintenance and repairs are paid for by you, these services may be performed by you or by any automotive service provider you choose. Scion will not deny a warranty claim solely because you used a service provider other than an Authorized Servicing Dealership for maintenance and repairs. However, any failure or noncompliance caused by improper maintenance or repairs is not covered by this warranty.

Replacement Parts To ensure optimum performance and maintain the quality built into your vehicle’s emission control systems, Scion recommends the use of Scion Authorized Parts when servicing or repairing the systems. Warranty coverage is not dependent upon the use of any particular brand of replacement parts, and you may elect to use non-Scion Authorized Parts for maintenance and repairs. However, use of replacement parts that are not equivalent in quality to Scion Authorized Parts may impair the effectiveness of the emission control systems. If you use replacement parts that have maintenance or replacement schedules different from those of Scion Authorized Parts, you must follow the maintenance and replacement schedules for the parts you are using. In addition, you should ensure that such parts are warranted by their manufacturers to be equivalent to Scion Authorized Parts.

If Your Vehicle Fails a Smog-Check Test If your vehicle fails a smog-check test, you may make a claim under the Emission Performance Warranty. To do so, take your vehicle to an Authorized Servicing Dealership and present a copy of the smog-check test report. Also, take your maintenance records in case they are needed. If your claim qualifies for coverage, the dealership will repair your vehicle within 30 days (unless a shorter period is required by law). If your claim is denied, Scion will notify you in writing of the reason within the same period. If we fail to do so, we will repair your vehicle free of charge. The only exceptions allowed are when you request or agree to a delay, or when a delay is caused by factors beyond the control of Scion or the dealership. For information on how to obtain service under the Emission Defect Warranty, see page xx, “Obtaining Warranty Service.”

17-P5VT-5

Repair Delays

If an Authorized Servicing Dealership is unable to complete repairs on your vehicle within 30 days, you may have the repairs made under Scion’s provisions for emergency warranty repairs. See page xx for details.

If You Have Questions If you have questions or concerns about your vehicle’s California emission warranty coverage, please follow the steps described under “If You Need Assistance” on page xx-xx. You may also request information from or report complaints to: California Air Resources Board, Mobile Source Control Division 9528 Telstar Avenue, P.O. Box 8001 El Monte, CA 91734-8001 (800)242-4450

Vehicles equipped with a California Certified Emission Control System that are registered and operated in California or any state that adopts California emission warranty provisions are covered by this warranty. Currently, Connecticut, Delaware, Maine, Maryland, Massachusetts, New Jersey, Oregon, Pennsylvania, Rhode Island, Vermont, and Washington are the other states to which this warranty applies. Vehicles covered by this warranty are also covered by the Federal Emission Control Warranty (see page xx).

17-P5VT-6

Attachments

The following pages include information that applies to all Scion vehicle warranties (including the California Emission Control Warranty). With the exception of the “General Warranty Provisions,” all of this information is referenced in the California Emission Control Warranty. Note: The “Warranty Parts List” information from the Federal Emission Control Warranty applies to the Federal Emission Control Warranty and California Emission Control Warranty only. This information is included as an attachment because it is referenced in the California Emission Control Warranty.

17-P5VT-7

Who Is the Warrantor Scion is the warrantor for these limited warranties. Scion is a marque of Toyota Motor Sales, U.S.A., Inc., 19001 South Western Avenue, Torrance, California 90509-2991, a California corporation.

Which Vehicles Are Covered These warranties apply to all 2015 model year Scion vehicles registered and normally operated in the United States, U.S. territories and Canada. Warranty coverage is automatically transferred at no cost to subsequent vehicle owners.

Multiple Warranty Conditions This booklet contains warranty terms and conditions that may vary depending on the part covered. A warranty for specific parts or systems, such as the Powertrain Warranty or Emission Performance Warranty, is governed by the coverage set forth in that warranty as well as the General Warranty Provisions.

When Warranty Begins The warranty period begins on the vehicle’s in-service date, which is the first date the vehicle is either delivered to an ultimate purchaser, leased, or used as a company car or demonstrator.

Repairs Made at No Charge Repairs and adjustments covered by these warranties are made at no charge for parts and labor.

Parts Replacement Any needed parts replacement will be made using new or remanufactured parts. The decision whether a part should be repaired or replaced will be made by the Authorized Servicing Dealership and/or Scion. Parts scheduled to be replaced as required maintenance are warranted until their first replacement only.

Authorized Servicing Dealerships For the purposes of these limited warranties, an Authorized Servicing Dealership is a Scion dealership or a Toyota dealership.

Scion Authorized Parts and Accessories Scion Authorized Parts are any Scion brand parts manufactured by or on behalf of Scion or Toyota Motor Corporation for use with Scion vehicles. Scion Authorized Accessories are any Scion brand accessories manufactured by or on behalf of Scion or Toyota Motor Corporation for use with Scion vehicles.

17-P5VT-8

Limitations

The performance of necessary repairs and adjustments is the exclusive remedy under these warranties or any implied warranties. Scion does not authorize any person to create for it any other obligation or liability in connection with this vehicle. Any implied warranty of merchantability or fitness for a particular purpose is limited to the duration of these written warranties. Some states do not allow restrictions on how long an implied warranty lasts, so this limitation may not apply to you.

Your Rights Under State Law These warranties give you specific legal rights. You may also have other rights that vary from state to state.

17-P5VT-9

What Is Not Covered

This warranty does not cover damage or failures resulting directly or indirectly from any of the following: Fire, accidents or theft Abuse or negligence Misuse – for example, racing or overloading Improper repairs Alteration or tampering, including installation of non-Scion Authorized Accessories Lack of or improper maintenance, including use of fluids other than those specified in the

Owner’s Manual Installation of non-Scion Authorized Parts Airborne chemicals, tree sap, road debris (including stone chips), rail dust, salt, hail, floods,

wind storms, lightning and other environmental conditions Water contamination This warranty also does not cover the following:

Tires Tires are covered by a separate warranty provided by the tire manufacturer. See page ##.

Normal Wear and Tear Noise, vibration, cosmetic conditions and other deterioration caused by normal wear and tear.

Maintenance Expense Normal maintenance services such as: Engine tune-ups Replacement of fluids and filters Lubrication Cleaning and polishing Replacement of spark plugs and fuses Replacement of worn wiper blades, brake pads/linings and clutch linings.

Vehicles With Altered Odometer Failure of a vehicle on which the odometer has been altered so that actual vehicle mileage

cannot be readily determined.

17-P5VT-10

Salvage or Total-Loss Vehicles Any vehicle that has ever been issued a “salvage” title or similar title under any state’s law; or has ever been declared a “total loss” or equivalent by a financial institution or insurer, such as by payment for a claim in lieu of repairs because the cost of repairs exceeded the cash value of the vehicle. This exclusion does not apply to the emission control warranties.

Incidental Damages Incidental or consequential damages associated with a vehicle failure. Such damages include but are not limited to inconvenience; the cost of transportation, telephone calls and lodging; the loss of personal or commercial property; and the loss of pay or revenue.

Disclaimer of Extra Expenses and Damages

The performance of necessary repairs and adjustments is the exclusive remedy under this warranty or any implied warranty. Scion does not authorize any person to create for it any other obligation or liability in connection with this vehicle. Scion shall not be liable for incidental or consequential damages resulting from breach of this written warranty or any implied warranty. Any implied warranty of merchantability or fitness for a particular purpose is limited to the duration of this written warranty, except in states where this limitation is not allowed.

17-P5VT-11

NEW VEHICLE LIMITED WARRANTY (for SCION)

DISPUTE RESOLUTION If a dispute arises regarding your warranty coverage, please follow the steps described under “If You Need Assistance” on pages 7-8. Please note that you must use the Dispute Settlement Program (or, in California, the CDSP) before seeking remedies through a court action pursuant to the Magnuson-Moss Warranty Act. You may also be required to use the Dispute Settlement Program or CDSP before seeking remedies under the “Lemon Laws” of your state. Please check the appropriate page of the Owner’s Warranty Rights Notification booklet (located in your glove box) for the requirements applicable to your state.

17-P5VT-12

Warranty Parts List

Air/Fuel Metering System

Air/fuel ratio feedback control system Cold-start enrichment system Deceleration control system Electronic fuel injection system components

-- Airflow sensor -- Engine control module (8/80) -- Throttle body -- Other components

Air Induction System

Intake manifold and/or intake air surge tank

Catalyst System Catalytic converter and protector (8/80) Constricted fuel filler neck Exhaust manifold Exhaust pipe (manifold to catalyst and/or catalyst to catalyst)

Evaporative Control System Charcoal canister Diaphragm valve Fuel filler cap Fuel tank Vapor liquid separator ____________________________ 8/80 = Covered for eight years or 80,000 miles, whichever occurs first.

17-P5VT-13

Exhaust Gas Recirculation (EGR) System

EGR gas temperature sensor EGR valve Associated parts

Ignition System

Distributor and internal parts Ignition coil and igniter Ignition wires Spark plugs*

Positive Crankcase Ventilation (PCV) System Oil filler cap PCV valve or orifice

Other Parts Used in Above Systems Data link connector (8/80) Hoses, clamps, fittings, tubing and mounting hardware Malfunction indicator light and bulb (8/80) Pulleys, belts and idlers Sealing gaskets and devices Sensors, solenoids, switches and valves

____________________________ * Warranted until first required maintenance under terms of the California Emission Control Warranty. 8/80 = Covered for eight years or 80,000 miles, whichever occurs first.

17-P5VT-14

General Information You are responsible for ensuring that your Scion is operated and maintained according to the instructions in the Owner’s Manual and this booklet. You should keep detailed records of vehicle maintenance, since under some circumstances they may be required for warranty coverage. These records should include date of service, mileage at time of service and a description of service performed and/or parts installed. For your convenience, a maintenance log is included in this booklet. If you sell your vehicle, you should give your maintenance records to the new owner. Scion will not deny a warranty claim solely because you do not have records to show that you maintained your vehicle. However, damage or failures caused by improper maintenance or lack of maintenance are not covered under warranty. Where to Go for Maintenance You may have maintenance performed on your vehicle by any qualified person or facility. However, Scion recommends having maintenance performed by an Authorized Servicing Dealership. Technicians at Authorized Servicing Dealerships are specially trained to maintain and repair Scion vehicles. They stay current on the latest service information through Scion technical bulletins, service publications and training courses. Many are also factory-certified. That means they have passed rigorous exams through both Scion and the National Institute for Automotive Service Excellence.

You can be confident you’re getting the best possible service for your vehicle when you take it to an Authorized Servicing Dealership. Plus, an Authorized Servicing Dealership will always use Scion Authorized Parts designed specifically for your vehicle.

17-P5VT-15

By Geographic Region

In the United States, U.S. Territories and Canada

To obtain warranty service in the United States, U.S. territories or Canada, take your vehicle to an Authorized Servicing Dealership. If your vehicle cannot be driven, contact your nearest Authorized Servicing Dealership for towing assistance. You do not have to pay for towing to the nearest Authorized Servicing Dealership if your vehicle is inoperable due to failure of a warranted part.

Outside the United States, U.S. Territories and Canada If you are using your vehicle outside the United States, U.S. territories and Canada and need warranty service, contact a local Authorized Servicing Dealership. Please note, however, that your vehicle may not be repaired free of charge because the local Authorized Servicing Dealership distributor may have no obligation to provide warranty service for your vehicle, and/or your vehicle may not comply with local regulatory or environmental requirements.

Emergency Repairs If your vehicle is inoperable or unsafe to drive and there is no Authorized Servicing Dealership reasonably available to make repairs, you may perform the repairs yourself or have them performed by another automotive service provider. Scion will reimburse you for any of the repairs that are covered by warranty. To receive reimbursement, present to an Authorized Servicing Dealership your paid repair invoices and any parts that were removed from the vehicle. You will be reimbursed for warranted parts at the manufacturer’s suggested retail price and warranted labor at a geographically appropriate hourly rate multiplied by Scion’s recommended time allowance for the repair. If your vehicle requires emergency repair, Scion assumes no liability for subsequent failures caused by improper repairs or the use of non-Scion Authorized Parts unless you have the vehicle properly repaired in a timely manner. To ensure that warranty coverage remains intact, have your vehicle inspected by an Authorized Servicing Dealership as soon as possible after an emergency repair.

17-P5VT-16

If You Need Assistance

Both Scion and your dealership want to make your Scion ownership experience easy and convenient. If you have a problem or concern - either during or after the warranty period - please take the following steps to ensure a quick response:

Step 1 Talk to a dealership manager, such as the service manager or customer relations manager. In most cases, you can reach a satisfactory solution at this step.

Step 2 If you’re not happy with the solution provided by the dealership, call Scion Customer Experience at (866) 70-SCION, or (866) 707-2466. To help everything move quickly, please have the following information at hand when you call: Your Scion’s vehicle identification number (located on the driver’s side corner of the

dashboard, under the window) Current mileage on your vehicle Name of your Scion dealership A Scion customer relations representative will help you work with the dealership to find a satisfactory solution.

17-P5VT-17

Step 3 If you’re still not satisfied after pursuing steps 1 and 2, Scion offers additional assistance through the Dispute Settlement Program, a dispute resolution program administered by the National Center for Dispute Settlement. The purpose of this program is to resolve disputes through arbitration — a process by which two parties authorize an independent third party to hear and resolve a dispute. The program is informal and free of charge. To request that your case be reviewed through the program, complete the customer claim form in the Owner’s Warranty Rights Notification booklet (found in your glove box) and mail it to:

National Center for Dispute Settlement P.O. Box 688 Mt.Clemens, MI 48046

If your customer claim form is missing, call Scion Customer Experience at (866) 70-SCION, or (866) 707-2466. When you call, be sure to have your vehicle identification number, your current mileage and the names of your selling and servicing dealerships. California Residents: Scion offers you assistance through an arbitration program called the California Dispute Settlement Program (CDSP). A brochure about the program is found in your glove box. For additional information, call Scion Customer Experience at (866) 70-SCION, or (866) 707-2466. You may also contact the CDSP directly at (888) 300-6237. Failure to use the CDSP may affect your rights and remedies under California’s “Lemon Laws.”

Important: You must use the Dispute Settlement Program (or, in California, the CDSP)before seeking remedies through a court action pursuant to the Magnuson-Moss Warranty Act. You may also be required to use the Dispute Settlement Program or CDSP before seeking remedies under the “Lemon Laws” of your state. Please see the Owner’s Warranty Rights Notification booklet for the requirements that apply to your state.

This information about the Dispute Settlement Programs is correct as of the date of printing. However, the programs may be changed without notice. For the most current information about the programs, call Scion Customer Experience at (866) 70-SCION, or (866) 707-2466.

17-P5VT-18

Initial Submission on 11/07/2014

iA Yaris

17-P5VT-19

17-4. Certification Summary Sheet E.O. #

Page 1/3

Test Group

GTYXR0107R12 Evap. STD LEV3 Opt1 LEV3 Opt2 LEV2 X

Evap. STD LEV3 Opt1 LEV3 Opt2 LEV2

Yes X No

CA 49S 50S X

PC X LDT1 LDT2 MDV1

MDV2 MDV3 MDV4

LEV3 Pooling Option

FTP NMOG+NOx Option1 Option2 X

SFTP NMOG+NOx Option1 Option2 X N/A

Evap Option1 Option2 N/A X

LEV3 LEV160 LEV3 ULEV125 LEV3 SULEV30 LEV2 LEV

LEV2 LEV(NMOG+NOx) LEV2 ULEV LEV2 ULEV(NMOG+NOx) X LEV2 SULEV

LEV2 SULEV(NMOG+NOx) U.S. EPA Tier2 Bin5

LEV3 Stand-alone )

LEV2 X EPA Std Tier2 Bin5

Exhaust Useful Life 120K X 150K X (FTP & HWY only)

Evap Useful Life 120K 150K X

FTP interim in-use Std NMOG+NOx PM NMOG+NOx&PM N/A X

NMOG+NOx PM NMOG+NOx&PM N/A X

Dedicated X Flex-Fuel Dual-Fuel Bi-Fuel

Gasoline X CNG M85 Diesel

LPG E85 Hybrid Electric Other (specify)

Cert Ph2 X Tier2 Unleaded E10-CARB E10-EPA

E85-CARB E85-EPA Diesel Other (specify)

Std X Equiv N/A

NMOG/NMHC 1.04 HCHO/NMHC

Measured x1.08 factor

Whole-Veh Full Mi Mfr Bench X

Other

CA X FED

SHED Pt Source X

1.　TWC/WU-TWC/HO2S/WR-HO2S/DFI

2.

I4 Valves per cylinder 4

1.　1.5L 1. 106/6000

2. 2.

Front X Mid Rear

FWD X RWD 4WD-FT 4WD-PT

Contents Sect/Page # Contents Sect/Page #

1 Authorized Representative 1-1

2 Fuel Specification -

3 Test Equipment - 23 Driveability Statements 8*1

4 Test procedure 12-2-1 24 Adjustable Parameters -

5 Mileage Accumulation Route 16-2*1 25 Tamper Resistance Method(s) -

6 Emission Warranty Statement 17-3 26 Fill Pipe Specifications 17-1

7 Maint : Cert/Req'd/Recm' - 27 High Altitude Compliance 8*1

8 Emiss Label/Vac Hose Dia 17-6 28 OBD Sys Incl Marked Revisions 16-3*1

9 Evap Control System 6, 12-1 29 I & M Test Procedure & Data 8*1

10 Engine Parameters 6, 12-1 30 50 Degree F Compliance 17-4

11 Fuel System 6 31 Manufacturer's RAF -

12 Ignition System 6, Part Ⅱ 32 Phase-In Schedule 16

13 Exhaust Control System 6, 12-1 33 NMOG Fleet Average Calculation 16

14 Proj Sales (LDV/MDV Split) 13-1 34 AB965 Credits/Withdrawals -

15 Vehicle Description 12-1 35 EPA certificate -

16 Evap Bench Test Procedure 16-2*1 36 Equiv NMOG Proc--ARB Approval N/A

17 R/L Temp & Press Profiles 12-2-4

18 EDV Selection -

19 Prod Veh same as Test Veh 8*1

20 Emission Label Durability 8*1

21 Test Vehicle Information DDV (EM) EDV (EM) EDV (Evap)

C/O or C/A MY & ID2016MY6DCP5VS1-004(Mazda)

2016MY6ECP5VS1-008(Mazda)

Vehicle Log Page (s) - - - -

Zero Mile Book Page (s) N/A N/A N/A N/A

Maint Logs & Engr Eval - - - -

*1: Please refer to the Mazda’s common section.

MODEL YEAR AIR RESOURCES BOARD CERTIFICATION SUMMARY SHEETPASSENGER CARS, LIGHT-DUTY TRUCKS AND MEDIUM-DUTY VEHICLES

Toyota Motor Corporation GTYXV01.5FEA

2016

Rated HP/RPM

DDV (Evap)

22 Gen Std, Increase in Emiss, Safety Meets allReqmts

8*1

LEV3 Composite fleet ave (Composite value bin:

Whole-Veh Accel Mi

Manufacturer

Evap. Family

ORVR

Engine Code Types

Vehicle Class(es)-Select all thatapply

Exhaust Std

SFTP Std

SFTP interim in-use Std

Fuel Usage

Fuel Type(s)

Exh Emission Test Fuel

NMOG Test Proc

Ratios (NMOG w/o RAF)

E10 Evap

Durability Service Accumulation

Evap Emis Test Proc

R/L Test Proc

PZEV Credit

2016MY6DCPES1-001(Mazda)6DCPES1-002(Mazda)

2016MY 6ECP5VS1-008(Mazda)

Exhaust ECS (Use abbreviations per SAE

J1930)

Engine Configuration

Displacement (Liters)

Engine location

Drive

17-P5VT-20

17-4. Certification Summary Sheet (contd.) California Review sheet

2016 Model-YEAR AIR RESOURCES BOARD CERTIFICATION REVIEW SHEET PASSENGER CARS, LIGHT-DUTY TRUCKS AND MEDIUM-DUTY VEHICLES E.O.#

page 2/3

Manufacture : TOYOTA Test Group : GTYXV01.5FEA Evaporative Family : GTYXR0107R12

PROJECTED EMISSIONS (grams/mile, except, grams/test for D+HS and grams/gallon for ORVR)(1),(2)

Test MPG FTP 20。F HWY 3-day

Vehicle ID Engine Code Loc. Trans ETW DPA CTY/HWY MileNMOG+

NoxCO HCHO *2 CO2 CH4 N2O *2 CO NMHC

NMOG+Nox

CO2 CH4 D+HS R/L ORVR

6ECP5VS1-008 6P5VSAAA MAZDA S6 2750 n/a 37.4 50K --- --- --- 234 *1 0.0017*1 --- 0.3 --- --- 179 *1 0.0007*1 --- --- ---/48.9 120K --- --- --- --- 0.009 --- --- 0.1 --- --- --- --- --- 0.02

150K 0.037 0.2 --- --- --- --- --- --- 0.0249 --- --- 0.26 0.00 ---*1 CO2 & CH4 are value at 4K mile.*2 Complying with HCHO & N2O standard based on the good engineering evaluation.

50K --- --- --- --- --- --- 10.0 --- --- --- --- --- --- ---120K --- --- --- --- 0.030 --- --- 0.3 --- --- --- --- --- 0.20150K 0.125 2.1 --- --- --- --- --- --- 0.125 --- --- 0.50 0.05 ---

Not Applicable X NMOG Methane (CNG or LNG only)

50K --- --- --- --- --- --- 0.00 --- --- --- --- --- --- ---120K --- --- --- --- 0.0069 --- --- 0.01 --- --- --- --- --- 0.000150K 0.0212 0.00 --- --- --- --- --- --- 0.0212 --- --- --- --- ---150K --- --- --- --- --- --- --- --- --- --- 0.012 0.000 ---

SFTP US06 SC03 50°F*3

Mile CO CO2 CO CO2 CO

4K 1.2 260 0.2 316 0.062 0.4

4K 8.0 --- 2.7 --- 0.250 2.1

*3 conducted by development vehicle

FTP HWY US06 SC03 20。F CO 50°FTest Number : GTKX10033475 GTKX10033480 GTKX10033481 GTKX10033482 GTKX10033479 -

Test Date : 09/08/2014 09/05/2014 09/05/2014 07/22/2014 08/06/2014 07/31/2014

Remarks

ApplicationProcessed by Date Reviewd by Date

0.02 0.03

0.14 0.20

HC-NM+Nox

Standards :

Certification Level :

NMOG+NoxHC-NM+Nox

Evaporative

(1) The Emission Data Vehicle(s) above comply with standards of:

The NMOG values include Reactivity Adjustment Factor(s) (RAF) of :

Emission values include DFs (with RAF deterioration, if applicable) of:

(2) Evaporative DFs are the average of :

17-P5VT-21

17-4. Certification Summary Sheet (contd.) E.O. #

Page 3/3

Test Group

GTYXR0107R12 Evap. STD LEV3 Opt1 LEV3 Opt2 LEV2 X

Evap. STD LEV3 Opt1 LEV3 Opt2 LEV2

Yes X No

CA 49S 50S X

PC X LDT1 LDT2 MDV1

MDV2 MDV3 MDV4

LEV3 Pooling Option

FTP NMOG+NOx Option1 Option2 X

SFTP NMOG+NOx Option1 Option2 X N/A

Evap Option1 Option2 N/A X

LEV3 LEV160 LEV3 ULEV125 LEV3 SULEV30 LEV2 LEV

LEV2 LEV(NMOG+NOx) LEV2 ULEV LEV2 ULEV(NMOG+NOx) X LEV2 SULEV

LEV2 SULEV(NMOG+NOx) U.S. EPA Tier2 Bin5

LEV3 Stand-alone )

LEV2 X EPA Std Tier2 Bin5

Exhaust Useful Life 120K X 150K X (FTP & HWY only)

Evap Useful Life 120K 150K X

FTP interim in-use Std NMOG+NOx PM NMOG+NOx&PM N/A X

NMOG+NOx PM NMOG+NOx&PM N/A X

Dedicated X Flex-Fuel Dual-Fuel Bi-Fuel

Gasoline X CNG M85 Diesel

LPG E85 Hybrid Electric Other (specify)

Cert Ph2 X Tier2 Unleaded E10-CARB E10-EPA

E85-CARB E85-EPA Diesel Other (specify)

Std X Equiv N/A

NMOG/NMHC 1.04 HCHO/NMHC

Measured x1.08 factor

Whole-Veh Full Mi Mfr Bench X

Other

CA X FED

SHED Pt Source X

1.　TWC/WU-TWC/HO2S/WR-HO2S/DFI

2.

I4 Valves per cylinder 4

1. 1.5L 1. 106/6000

2. 2.

Front X Mid Rear

FWD X RWD 4WD-FT 4WD-PT

Vehicle Models(if coded seeattachment)

Trans.(M5, A4 etc.)

ETW or TestWt.

DPA or RLHPIgnition　*1(ECM/PCM)Part NO.

EGR system *1 Part. NO

P5DT-18881

P5DV-18881 Warm-Up : P544-2050XUnderfloor : P544-2055X

n/aUnderfloor : P544-2055X

ORVR

MODEL YEAR AIR RESOURCES BOARD CERTIFICATION SUMMARY SHEETPASSENGER CARS, LIGHT-DUTY TRUCKS AND MEDIUM-DUTY VEHICLES

Toyota Motor Corporation GTYXV01.5FEA

2016

Manufacturer

Evap. Family

LEV3 Composite fleet ave (Composite value bin:

Whole-Veh Accel Mi

Fuel Type(s)

Exh Emission Test Fuel

NMOG Test Proc

Warm-Up : P544-2050X

Catalytic Converter　*1Part .NO

Rated HP/RPM

M6 2750 n/aiAYaris 1.5LiAYaris 1.5L

PZEV Credit

Exhaust ECS (Use abbreviations per SAE

J1930)

Engine Configuration

Engine Code Types

Vehicle Class(es)-Select all thatapply

Exhaust Std

SFTP Std

SFTP interim in-use Std

Fuel Usage

6P5VSAAA(50ST)

6P5V3AAA(50ST)6P5V3AAB(50ST)

Ratios (NMOG w/o RAF)

E10 Evap

Durability Service Accumulation

Evap Emis Test Proc

R/L Test Proc

S6

Displacement (Liters)

Engine location

Drive

Engine Code(also list CA/49ST/50ST)

*1 Initial parts number only, for update refer to Individual application Part 2.

2750 n/an/a

17-P5VT-22

17-5. Fuel Evaporative Emission Results Not applicable 17-6. Vehicle Emission Control Information label

18-P5VT-1

18. Information on Service of Process

Kevin Webber General Manager Toyota Motor Engineering & Manufacturing North America, Inc. Toyota Technical Center 1555 Woodridge Avenue Ann Arbor, Michigan 48105 U.S.A. Phone No. (734) 995 - 2600 Fax No. (734) 995 - 9049 E-Mail [email protected]

19-P5VT-1

19. REVISIONS No. Date Pages Affected Description - 04/01/2015 - Issued.

Documents

Toyota Motor Corporation Application For Certification