Upload
advocate
View
359
Download
10
Embed Size (px)
Citation preview
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
1/211
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
TECHNICAL MANUAL
OPERATORS AND FIELD LEVEL
MAINTENANCE MANUAL
(INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST)
FOR
HEMTT-BASED WATER TENDER (HEWATT)
MODEL M1158
NSN 2320-01-528-6294
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
*TM 9-2320-328-13&P-1
HWT0216
* SUPERSEDURE NOTICE: This manual supersedes TM 9-2320-328-13&P-1 dated 30 April 2008.
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
HEADQUARTERS, DEPARTMENT OF THE ARMY
MARCH 2009
DRAFT
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
2/211
This Page Intentionally Left Blank
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
3/211
TM 9-2320-328-13&P-1
a
DRAFTWARNING SUMMARY
This list summarizes critical warnings in this technical manual. They are repeated here to let you know how
important they are. Study these warnings carefully. They can save your life and the lives of personnel you work
with. If there is any doubt about handling tools, materials, equipment, and procedures, see TB 43-0216, Safety and
Hazard Warnings for Operation and Maintenance of TACOM Equipment.
FOR INFORMATION ON FIRST AID, REFER TO FM 4-25.11.
OPERATION HAZARDS- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
CARBON MONOXIDE (EXHAUST GAS) CAN CAUSE DEATH
Carbon monoxide is without color or smell, but can cause death. Breathing air with
carbon monoxide produces symptoms of headache, dizziness, loss of muscular
control, a sleepy feeling, and coma. Brain damage or death can result from heavy
exposure. Carbon monoxide occurs in the exhaust fumes of fuel-burning heaters
and internal combustion engines. Carbon monoxide can become dangerously
concentrated under conditions of no ventilation. Precautions must be followed to
ensure crew safety when the personnel heater or engine of any vehicle is operated
for any purpose.
DO NOT operate personnel heater or engine of vehicle in a closed place without
proper ventilation.
DO NOT drive any vehicle with inspection plates, cover plates, or engine
compartment covers removed unless necessary for maintenance purposes.
BE ALERT at all times during vehicle operation for exhaust odors and exposure
symptoms. If either are present, IMMEDIATELY VENTILATE personnel
compartments. If symptoms persist, remove affected crew to fresh air and keep
warm. DO NOT PERMIT PHYSICAL EXERCISE. If necessary, give artificial
respiration and get immediate medical attention. For artificial respiration, refer to
FM 4-25.11.
BE AWARE that the gas particulate filter unit or field protection mask for nuclear-
biological-chemical protection WILL NOT offer safety from carbon monoxide
poisoning.
THE BEST DEFENSE AGAINST CARBON MONOXIDE POISONING IS GOOD
VENTILATION.
WARNING
ICON 30
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
4/211
TM 9-2320-328-13&P-1
b
DRAFT- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Personnel hearing can be PERMANENTLY DAMAGED if exposed to constant highnoise levels of 85 dB or greater. Wear approved hearing protection devices when
working in high noise level areas. Hearing loss occurs gradually, but becomes
permanent over time.
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Diesel fuel compartment heaters come on automatically when truck engine is
running and air temperature is below 39F (4C). CARBON MONOXIDE (EXHAUST
GAS) CAN KILL YOU. Carbon monoxide is a colorless, odorless, DEADLY
POISONOUS gas and when breathed, deprives body of oxygen and causes
SUFFOCATION. Breathing air with carbon monoxide produces symptoms of
headache, dizziness, loss of muscular control, a sleepy feeling, and coma.
Permanent BRAIN DAMAGE or DEATH can result from severe exposure.
Precautions MUST be followed to ensure personnel are safe whenever
compartment heaters or engine are operated for any purpose. Injury to personnel
may result.
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
DO NOT operate compartment heaters or engine of truck in enclosed area without
adequate ventilation. BE ALERT at all times whenever BATTERY switch is ON,
truck engine is running, and air temperature is below 39F (4C) for exhaust
symptoms. If either are present, IMMEDIATELY EVACUATE AND VENTILATE the
area. Affected personnel treatment shall be: expose to fresh air; keep warm; DO
NOT PERMIT PHYSICAL EXERCISE; if necessary, give artificial respiration as
described in FM 4-25.11 and get medical attention. BE AWARE; neither the gasparticulate filter unit nor field protection mask for nuclear-biological-chemical
protection will protect you from carbon monoxide poisoning. THE BEST DEFENSE
AGAINST CARBON MONOXIDE POISONING IS GOOD VENTILATION.
WARNING
ICON 1
WARNING
ICON 30
WARNING
ICON 30
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
5/211
TM 9-2320-328-13&P-1
c
DRAFTMODIFICATION HAZARD
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Unauthorized modifications to, alterations to, or installations of this equipment are
prohibited and are in violation of AR 750-10. Any unauthorized modifications,
alterations, or installations could result in injury or death to personnel or damage to
equipment.
HIGH-PRESSURE HYDRAULIC SYSTEM- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Hydraulic systems can cause serious injury if high-pressure lines or equipment
fails.
Never work on hydraulic systems or equipment unless there is another person
nearby who is familiar with the operation and hazards of the equipment and can
give first aid.
Be sure to wear proper eye protection to prevent injury or death. Never disconnect
any hydraulic hose or part while the engine is running. Allow several minutes to
elapse after shutting off engine, to allow pressure to relieve itself, before attempting
to remove hoses. Failure to comply may result in injury to personnel.
ELECTRICAL SYSTEM- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Remove all jewelry, such as rings, dog tags, bracelets, etc. If jewelry or tools
contact electrical circuits, a direct short may result. Damage to equipment or death
to personnel may occur.
Do not smoke, use open flame, make sparks or other ignition sources aroundbatteries. A battery giving off gas could explode and cause injury to personnel.
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
WARNING
ICON 72
WARNING
ICON 66,26
WARNING
ICON 3,25
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
6/211
TM 9-2320-328-13&P-1
d
DRAFTSOLVENT CLEANING COMPOUND- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Solvent cleaning compound MIL-PRF-680 Type II and III may be irritating to the eyes
and skin. Use protective gloves and goggles. Use in well-ventilated areas. Use
respirator as needed. Accidental ingestion can cause irritation of digestive tract
and respiratory tract, may cause lung and central nervous system damage. Can be
fatal if swallowed. Inhalation of high/massive concentrations can cause coma or be
fatal. First aid for ingestion: do not induce vomiting. Seek immediate medical
attention. First aid for skin contact: remove contaminated clothing. Wash skin
thoroughly with soap and water. If symptoms persist, seek medical attention. First
aid for eye contact: flush with water for 15 minutes or until irritation subsides. If
symptoms persist, seek medical attention. First aid for inhalation: move to fresh
air. If not breathing, provide artificial respiration. If symptoms persist, seek
medical attention. Keep away from open flames and other sources of ignition.
Failure to follow this warning may result in injury or death to personnel.
The flashpoint for Type II solvent cleaning compound is 141 to 198F (61 to
92C) and Type III is 200 to 241F (93 to 116C).
Improper cleaning methods and use of unauthorized cleaning solvents may
injure personnel and damage equipment.
Fire extinguishers should be placed nearby when using solvent cleaning
compound. Failure to follow this warning may result in injury or death.
Cloths or rags saturated with solvent cleaning compound must be disposed
of IAW authorized facilitys procedures. Failure to follow this warning may
result in injury.
Eye shields must be worn when cleaning with a wire brush. Flying rust and
metal particle may cause injury.
ADHESIVE- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Adhesives, solvents, and sealing compounds can burn easily, can give off harmful
vapors, and are harmful to skin and clothing. To avoid injury or death, keep away
from open fire and use in well-ventilated area. If adhesive, solvent, or sealing
compound gets on skin or clothing, wash immediately with soap and water.
WARNING
ICON 26,44,30,36,27
WARNING
ICON 30, 44, 27
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
7/211
TM 9-2320-328-13&P-1
e/(f blank)
DRAFTFLAMMABLE LIQUID AND COMBUSTIBLE VAPOR
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Gasoline, fuel oil, lubricating oil, grease, paint, paint thinner, cleaning solvents, and
other combustible liquids present a serious fire hazard. Always store combustible
liquids in approved containers and in their designated compartments or deck
storage locations. Ensure exhaust and ventilation fans are operating while using
cleaning solvents or paint products. Never store or charge batteries in a confined
space without ventilation or near electrical equipment.
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Fuel is very flammable and can explode easily. To avoid serious injury or death,
keep fuel away form open fire and keep fire extinguisher within easy reach when
working with fuel. Do not work on fuel system when engine is hot. Fuel can be
ignited by hot engine. While working with fuel, post signs that read NO SMOKING
WITHIN 5O FEET OF VEHICLE.
PARTS UNDER PRESSURE- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
Wear safety goggles and use caution when removing or installing springs, snap
rings, retaining rings, and other parts under spring tension. These parts can act as
projectiles, resulting in serious injury to personnel.
WARNING
ICON 30,25
WARNING
ICON 36,25
WARNING
ICON 26
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
8/211
This Page Intentionally Left Blank
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
9/211
DRAFT TM 9-2320-328-13&P-1LIST OF EFFECTIVE PAGES/WORK PACKAGES
NOTE: This manual supersedes TM 9-2320-328-13&P-1 dated 30 April 2008. Zero in the Change No. column
indicates an original page or work package.
TOTAL NUMBER OF VOLUMES IS 3, TOTAL NUMBER OF PAGES
FOR FRONT AND REAR MATTER IS 186 AND TOTAL NUMBER OF
WORK PACKAGES IS 400, CONSISTING OF THE FOLLOWING:
Date of issue for the original manual is:
Original 15 March 2009
A
Page/WP No. Change No. Page/WP No. Change No.
VOLUME 1
Cover. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0
Warning Summary (6 pgs). . . . . . . . . . . . . . . . . . 0
i thru xxii . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0
xxiii/(xxiv blank) . . . . . . . . . . . . . . . . . . . . . . . . . . 0
Chp 1 Title page . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0001 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0002 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0003 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
Chp 2 Title page . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0004 (22 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0005 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0006 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0007 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0008 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0009 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0010 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0011 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0012 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0013 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0014 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0015 (18 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0016 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0017 (36 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0018 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0019 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0020 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0021 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0022 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0023 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0024 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0025 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0026 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0027 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0028 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0029 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0030 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0031 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0032 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0033 (20 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0034 (14 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0035 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0036 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0037 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0038 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0039 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0040 (16 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0Chp 3 Title page . . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0041 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0042 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0043 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0044 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0045 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0046 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0047 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0048 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0049 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0050 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0051 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0052 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0053 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0054 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0055 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0056 (18 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0057 (40 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0058 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0059 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
10/211
TM 9-2320-328-13&P-1
B
DRAFTPage/WP No. Change No. Page/WP No. Change No.
WP 0060 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0061 (18 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0062 (18 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0063 (52 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0064 (28 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0065 (14 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0066 (10 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0067 (10 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0068 (18 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0069 (18 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0070 (12 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0071 (26 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0072 (116 pgs). . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0073 (28 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0074 (8 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0075 (16 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0076 (28 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0077 (14 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0078 (2 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0079 (10 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0080 (12 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0081 (18 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0082 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0083 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0084 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0085 (22 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0086 (14 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0087 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0088 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0089 (44 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0090 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0091 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0092 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0093 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0094 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0095 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0096 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0097 (16 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0098 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0099 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0100 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0101 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0102 (14 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0103 (24 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0104 (8 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0105 (20 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0106 (26 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0107 (24 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0108 (12 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0109 (14 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0110 (12 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0111 (16 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0112 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
INDEX-1 thru INDEX-24 . . . . . . . . . . . . . . . . . . . 0
INDEX-25/(INDEX-26 blank). . . . . . . . . . . . . . . . 0
VOLUME 2
Cover. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0
Warning Summary (6 pgs). . . . . . . . . . . . . . . . . . 0
i thru x . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0
xi/(xii blank) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0
Chp 3 Title Cont. page. . . . . . . . . . . . . . . . . . . . . 0
WP 0113 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0114 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0115 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0116 (24 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0117 (18 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0118 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0119 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0120 (32 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0121 (18 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0122 (12 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0123 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0124 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0125 (12 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0126 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0127 (26 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
Chp 4 Title page . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0128 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0129 (36 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
Chp 5 Title page . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0130 (12 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0131 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0132 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0133 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0134 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0135 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0136 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0137 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0138 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0139 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0140 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0141 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0142 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0143 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0144 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0145 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0146 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
11/211
TM 9-2320-328-13&P-1
C
DRAFTPage/WP No. Change No. Page/WP No. Change No.
WP 0147 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0148 (12 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0149 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0150 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0151 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0152 (14 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0153 (12 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0154 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0155 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0156 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0157 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0158 (20 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0159 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0160 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0161 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0162 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0163 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0164 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0165 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0166 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0167 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0168 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0169 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0170 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0171 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0172 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0173 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0174 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0175 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0176 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0177 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0178 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0179 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0180 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0181 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0182 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0183 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0184 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0185 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0186 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0187 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0188 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0189 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0190 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0191 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0192 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0193 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0194 (14 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0195 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0196 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0197 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0198 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0199 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0200 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0201 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0202 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0203 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0204 (18 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0205 (32 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0206 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0207 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0208 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0209 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0210 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0211 (2 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0212 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0213 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0214 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0215 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0216 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0217 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0218 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0219 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0220 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0221 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0222 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0223 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0224 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0225 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0226 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0227 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0228 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0229 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0230 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0231 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0232 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0233 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0234 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0235 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0236 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0237 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0238 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0239 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0240 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0241 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0242 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0243 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0244 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0245 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0246 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
12/211
TM 9-2320-328-13&P-1
D
DRAFTPage/WP No. Change No. Page/WP No. Change No.
WP 0247 (12 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0248 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0249 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0250 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0251 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0252 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0253 (2 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0254 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0255 (2 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0256 (8 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0257 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0258 (2 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0259 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0260 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0261 (2 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0262 (2 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0263 (2 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0264 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0265 (8 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0266 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0267 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0268 (8 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0269 (2 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0270 (12 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0271 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0272 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0273 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0274 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0275 (2 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0276 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0277 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0278 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0279 (16 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0280 (12 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0281 (8 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0282 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0283 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0284 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0285 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0286 (12 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0287 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0288 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0289 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0290 (6 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0291 (8 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0292 (20 pgs). . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0293 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0294 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0295 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0296 (4 pgs). . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0297 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0298 (20 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0299 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0300 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0301 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0302 (32 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0303 (34 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0304 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0305 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0306 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0307 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0308 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0309 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0310 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0311 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0312 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0313 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0314 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0315 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0316 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0317 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0318 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0319 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0320 (16 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0321 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0322 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0323 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0324 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
INDEX-1 thru INDEX-24 . . . . . . . . . . . . . . . . . . . 0
INDEX-25/(INDEX-26 blank). . . . . . . . . . . . . . . . 0
VOLUME 3
Cover. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0
Warning Summary (6 pgs). . . . . . . . . . . . . . . . . . 0
i thru vi. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0
vii/(viii blank) . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0
Chp 5 Title Cont. page. . . . . . . . . . . . . . . . . . . . . 0
WP 0325 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0326 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0327 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0328 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0329 (12 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0330 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0331 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0332 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0333 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0334 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0335 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
13/211
TM 9-2320-328-13&P-1
E/(F blank)
DRAFTPage/WP No. Change No. Page/WP No. Change No.
WP 0336 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0337 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0338 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0339 (28 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0340 (26 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0341 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0342 (16 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0343 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0344 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0345 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0346 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0347 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0348 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0349 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0350 (14 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0351 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0352 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0353 (12 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0354 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0355 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0356 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0357 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0358 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0359 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0360 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0361 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0362 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0363 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0364 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0365 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0366 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0367 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0368 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0369 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0370 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0371 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0372 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0373 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0374 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0375 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0376 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0377 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0378 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0379 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0380 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0381 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0382 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0383 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0384 (10 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0385 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0386 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0387 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
Chp 6 Title page . . . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0388 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0389 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0390 (6 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0391 (284 pgs) . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0392 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0393 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0394 (18 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0395 (28 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0
Chp 7 Title page . . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0396 (2 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0397 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0398 (14 pgs) . . . . . . . . . . . . . . . . . . . . . . . . 0WP 0399 (8 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
WP 0400 (4 pgs) . . . . . . . . . . . . . . . . . . . . . . . . . 0
INDEX-1 thru INDEX-24. . . . . . . . . . . . . . . . . . . . 0
INDEX-25/(INDEX-26 blank) . . . . . . . . . . . . . . . . 0
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
14/211
This Page Intentionally Left Blank
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
15/211
DRAFT *TM 9-2320-328-13&P-1HEADQUARTERS
DEPARTMENT OF THE ARMY
WASHINGTON, D.C., 15 MARCH 2009
TECHNICAL MANUAL
OPERATORS AND FIELD LEVELMAINTENANCE MANUAL
(INCLUDING REPAIR PARTS AND SPECIAL TOOLS LIST)
FOR
HEMTT-BASED WATER TENDER (HEWATT)
MODEL M1158
NSN 2320-01-528-6294
- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
REPORTING ERRORS AND RECOMMENDING IMPROVEMENTS
You can help improve this publication. If you find any errors, or if you would like to recommend any
improvements to the procedures in this publication, please let us know. The preferred method is to submit
you DA Form 2028 (Recommended Changes to Publications and Blank Forms) through the Internet, on
the Army Electronic Product Support (AEPS) website. The Internet address is https://aeps.ria.army.mil.
The DA Form 2028 is located under the Public Applications section in the AEPS Public Home Page. Fill
out the form and click on SUBMIT. Using this form on the AEPS will enable us to respond quicker to your
comments and better manage the DA Form 2028 program. You may also mail, e-mail, or fax yourcomments of DA Form 2028 directly to the U.S. Army TACOM Life Cycle Management Command. The
postal mail address is U.S. Army TACOM Life Cycle Management Command, ATTN: AMSTA-LC-LMPP /
TECH PUBS, 1 Rock Island Arsenal, Rock Island, IL 61299-7630. The e-mail address is
[email protected]. The fax number is DSN 793-0726 or Commercial (309) 782-0726.
i
* SUPERSEDURE NOTICE: This manual supersedes TM 9-2320-328-13&P-1 dated 30 April 2008.
DISTRIBUTION STATEMENT A: Approved for public release; distribution is unlimited.
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
16/211
TM 9-2320-328-13&P-1
ii
DRAFT- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - 0
TABLE OF CONTENTS
WP Sequence No.
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
VOLUME 1
CHAPTER 1 GENERAL INFORMATION AND DATA
0001 General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0001
0002 Equipment Description and Data . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0002
Table 1. Equipment Data. . . . . . . . . . . . . . . . . . . . . . . . . . . . 0002-4
0003 Theory of Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0003
CHAPTER 2 OPERATOR INSTRUCTIONS
OPERATION UNDER USUAL CONDITIONS
0004 Description and Use of Operators Controls and Indicators . . . . . . . . . . . . . . . . . . . . WP 0004
Figure 1. Cab Instrument Panel - Upper Left.. . . . . . . . . . . . 0004-1
Figure 2. Cab Instrument Panel - Lower Left.. . . . . . . . . . . . 0004-2
Figure 3. Cab Instrument Panel - Lower Right. . . . . . . . . . . 0004-3
Figure 4. Cab Instrument Panel - Upper Right/Radio. . . . . . 0004-4
Figure 5. Cab Instrument Panel - Upper Right/Electronic
Siren Controls. . . . . . . . . . . . . . . . . . . . . . . . . . . 0004-5
Figure 6. Personnel Cab. . . . . . . . . . . . . . . . . . . . . . . . . . . . 0004-6
Figure 7. Bumper Turret Controls. . . . . . . . . . . . . . . . . . . . . 0004-7
Figure 8. Personnel Cab - Center Console. . . . . . . . . . . . . . 0004-9
Figure 9. Pump Operators Panel - Left.. . . . . . . . . . . . . . . 0004-10
Figure 10. Pump Operators Panel - Center Left. . . . . . . . . 0004-11
Figure 11. Pump Operators Panel - Upper Center/
Bottom Right. . . . . . . . . . . . . . . . . . . . . . . . . . . 0004-12
Figure 12. Pump Operators Panel - Electronic Valves. . . . 0004-13
Figure 13. Pump Operators Panel - Electronic
Metering Valves.. . . . . . . . . . . . . . . . . . . . . . . . 0004-14
Figure 14. Cab/Pump Operators Panel Pressure
Governor Controls.. . . . . . . . . . . . . . . . . . . . . . 0004-15
Figure 15. Driver Side - Pump House. . . . . . . . . . . . . . . . . 0004-16
Figure 16. Passenger Side - Pump House. . . . . . . . . . . . . 0004-18
Figure 17. Driver Side - Rear Vehicle. . . . . . . . . . . . . . . . . 0004-20
Figure 18. Pump House Top. . . . . . . . . . . . . . . . . . . . . . . . 0004-21
Figure 19. Vehicle Water Tank Body - Rear/Sides.. . . . . . . 0004-22
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
17/211
TM 9-2320-328-13&P-1
iii
DRAFT
0005 Prepare to Operate Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0005
0006 Preparation for Operation-Operational Modes. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0006
0007 Batteries Connect/Disconnect . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0007
0008 Compartment Door Open/Close . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0008
0009 Pump House Access Door Assembly Open/Close . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0009
0010 Pump Operators Panel Cover Open/Close. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0010
0011 SINCGARS Cover Door Open/Close. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0011
0012 Right Rear Access Ladder Stow/Unstow. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0012
0013 Portable Ladder (Folding) Stow/Unstow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0013
0014 Portable Water Tank Stow/Unstow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0014
0015 Water Tank Fill/Drain. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0015
0016 Priming Water Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0016
0017 Pressure Governor Operation (Cab and Pump Operators Panel) . . . . . . . . . . . . . . . WP 0017
Figure 1. Home Screen for the HEWATT Cab Display. . . . . . 0017-2
Figure 2. Home Screen When OK To Pump Interlocks
Have Been Satisfied.. . . . . . . . . . . . . . . . . . . . . . 0017-4
Figure 3. Home Screen When a Warning Event Occurs. . . . 0017-5
Figure 4. Home Screen When a Caution Event Occurs. . . . . 0017-6
Figure 5. An Example of the Home Screen When aConfirmation OK Message Appears. . . . . . . . . 0017-7
Figure 6. The Home Screen Once the Mode Button Is
Pushed To Go Into Pressure Mode. . . . . . . . . . . 0017-8
Figure 7. The Home Screen Once the User Presses
the OK Button Within 3 Seconds To Go To
Pressure Mode.. . . . . . . . . . . . . . . . . . . . . . . . . . 0017-8
Figure 8. The Home Screen If the User Does Not Press
the OK Button Within 3 Seconds To Go To
Pressure Mode.. . . . . . . . . . . . . . . . . . . . . . . . . . 0017-9
Figure 9. The Home Screen Once the Mode Button Is
Pushed To Go Into Manual Mode.. . . . . . . . . . . . 0017-9
Figure 10. The Home Screen Once the User Presses the
OK Button Within 3 Seconds To Go To Manual
Mode With the Pressure On the Pump Under
10 psi (68.9 kPa). . . . . . . . . . . . . . . . . . . . . . . . 0017-10
TABLE OF CONTENTS (CONTINUED)
WP Sequence No
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
18/211
TM 9-2320-328-13&P-1
iv
DRAFT
Figure 11. The Home Screen Once the User Presses
the OK Button Within 3 Seconds To Go ToManual Mode With the Pressure On the
Pump Over 10 psi (68.9 kPa). . . . . . . . . . . . . . 0017-10
Figure 12. The Home Screen If the User Does Not Press
the OK Button Within 3 Seconds
To Go To Manual Mode. . . . . . . . . . . . . . . . . . . 0017-11
Figure 13. The Home Screen Once the Preset Button Is
Pushed To Go To a Preset Pressure.. . . . . . . . 0017-12
Figure 14. The Home Screen Once the Preset Pressure
Value Is Reached. . . . . . . . . . . . . . . . . . . . . . . 0017-13
Figure 15. The Home Screen If the Preset Pressure
Cannot Be Reached and the Engine RPMIs Above 1200. . . . . . . . . . . . . . . . . . . . . . . . . . 0017-14
Figure 16. The Home Screen If the User Does Not Press
the OK Button Within 3 Seconds
To Go To a Preset Pressure. . . . . . . . . . . . . . . 0017-14
Figure 17. The Home Screen Once the Idle Button Is
Pushed To Go To Idle Mode. . . . . . . . . . . . . . . 0017-15
Figure 18. The Home Screen If the User Presses the OK
Button Within 3 Seconds To Go To Idle Mode.. 0017-15
Figure 19. The Home Screen If the User Does Not Press
the OK Button Within 3 Seconds To Go To
Idle Mode. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0017-16
Figure 20. The Display Enable Screen. . . . . . . . . . . . . . . . 0017-17
Figure 21. Home Screen for the HEWATT Pump Panel
Display.. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0017-21
Figure 22. Home Screen When Throttle Ready
Interlocks Have Been Satisfied. . . . . . . . . . . . . 0017-22
Figure 23. Home Screen When a Warning Event Occurs. . 0017-23
Figure 24. Home Screen When a Caution Event Occurs. . 0017-24
Figure 25. An Example of the Home Screen When a
Confirmation OK Message Appears. . . . . . . . 0017-25
Figure 26. The Home Screen Once the Mode Button Is
Pushed To Go Into Pressure Mode. . . . . . . . . . 0017-26
Figure 27. The Home Screen Once the User Presses
the OK Button Within 3 Seconds To Go To
Pressure Mode. . . . . . . . . . . . . . . . . . . . . . . . . 0017-26
TABLE OF CONTENTS (CONTINUED)
WP Sequence No.
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
19/211
TM 9-2320-328-13&P-1
v
DRAFT
Figure 28. The Home Screen If the User Does Not Press
the OK Button Within 3 Seconds To Go ToPressure Mode.. . . . . . . . . . . . . . . . . . . . . . . . . 0017-27
Figure 29. The Home Screen Once the Mode Button Is
Pushed To Go Into Manual Mode.. . . . . . . . . . . 0017-27
Figure 30. The Home Screen Once the User Presses
the OK Button Within 3 Seconds To Go To
Manual Mode With the Pressure On the
Pump Under 10 psi (68.9 kPa).. . . . . . . . . . . . . 0017-28
Figure 31. The Home Screen Once the User Presses
the OK Button Within 3 Seconds To Go To
Manual Mode With the Pressure On the
Pump Over 10 psi (68.9 kPa). . . . . . . . . . . . . . . 0017-28
Figure 32. The Home Screen If the User Does Not Press
the OK Button Within 3 Seconds To Go To
Manual Mode. . . . . . . . . . . . . . . . . . . . . . . . . . . 0017-29
Figure 33. The Home Screen Once the Preset Button Is
Pushed To Go To a Preset Pressure. . . . . . . . . 0017-30
Figure 34. The Home Screen Once the Preset Pressure
Value Is Reached. . . . . . . . . . . . . . . . . . . . . . . . 0017-30
Figure 35. The Home Screen If the Preset Pressure
Cannot Be Reached and the Engine RPM
Is Above 1000. . . . . . . . . . . . . . . . . . . . . . . . . . 0017-31
Figure 36. The Home Screen If the User Does Not Pressthe OK Button Within 3 Seconds To Go To a
Preset Pressure. . . . . . . . . . . . . . . . . . . . . . . . . 0017-31
Figure 37. The Home Screen Once the Idle Button Is
Pushed To Go To Idle Mode.. . . . . . . . . . . . . . . 0017-32
Figure 38. The Home Screen If the User Presses the OK
Button Within 3 Seconds To Go To Idle Mode. . 0017-32
Figure 39. The Home Screen If the User Does Not Press
the OK Button Within 3 Seconds To Go To
Idle Mode. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0017-33
Figure 40. The Display Enable Screen. . . . . . . . . . . . . . . . . 0017-34
0018 Pumping from Draft (Main Inlet). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0018
0019 Pumping from Onboard Water Tank . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0019
0020 Pumping from Hydrant or In Relay (Positive Water Sources) . . . . . . . . . . . . . . . . . . . WP 0020
0021 Foam System General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0021
0022 Foam Agent Filling/Draining/Flushing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0022
TABLE OF CONTENTS (CONTINUED)
WP Sequence No
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
20/211
TM 9-2320-328-13&P-1
vi
DRAFT
0023 Foam System and Instrument Panel Standby Mode . . . . . . . . . . . . . . . . . . . . . . . . . WP 0023
0024 Foam System Operating Procedures (Cab and Pump Operators Panel) . . . . . . . . . WP 0024
0025 Hose Reel Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0025
0026 Windshield Deluge Operation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0026
0027 Bumper Turret Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0027
0028 Under Truck Nozzles and Pump and Roll/Drive Operations . . . . . . . . . . . . . . . . . . . WP 0028
0029 Foam System Flushing. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0029
0030 Post Operation Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0030
0031 Water Pump and Water Tank Flush . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0031
0032 Preparation for Storage or Shipment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0032
0033 Pump and Plumbing Blow Out Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0033
OPERATION UNDER UNUSUAL CONDITIONS
0034 Operation in Cold Environment, -25 to 32F (-32 to 0C) . . . . . . . . . . . . . . . . . . . . . . WP 0034
0035 Operation in Extreme Hot Environment 105F (40C) or Above . . . . . . . . . . . . . . . . WP 0035
0036 Manual Hose Reel Rewind . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0036
0037 Manual Priming Pump Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0037
0038 Pumping Operations (Manual Override). . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0038
0039 Stowage and Data Plate Guide . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0039
0040 On-Truck Load Plan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0040
Figure 1. Location of Stowage Compartments.. . . . . . . . . . . 0040-1
Table 1. Load Plan (Cab). . . . . . . . . . . . . . . . . . . . . . . . . . . . 0040-2
Table 2. Load Plan (Cab). . . . . . . . . . . . . . . . . . . . . . . . . . . . 0040-3
Table 3. Load Plan (Cab). . . . . . . . . . . . . . . . . . . . . . . . . . . . 0040-4
Table 4. Load Plan (Stowage Compartment D1). . . . . . . . . . 0040-5
Table 5. Load Plan (Stowage Compartment D2). . . . . . . . . . 0040-6
Table 6. Load Plan (Stowage Compartment D3). . . . . . . . . . 0040-7
Table 7. Load Plan (Stowage Compartment D4). . . . . . . . . . 0040-8
Table 8. Load Plan (Stowage Compartment P1). . . . . . . . . . 0040-9
Table 9. Load Plan (Stowage Compartment P2). . . . . . . . . 0040-10
Table 10. Load Plan (Stowage Compartment P3). . . . . . . . 0040-11
Table 11. Load Plan (Stowage Compartments R1 and R2). 0040-12
Table 12. Load Plan (Stowage Compartment R3). . . . . . . . 0040-13
TABLE OF CONTENTS (CONTINUED)
WP Sequence No.
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
21/211
TM 9-2320-328-13&P-1
vii
DRAFT
Table 13. Load Plan (Stowage Compartment T1).. . . . . . . . 0040-14
Table 14. Load Plan (Stowage Compartment T2).. . . . . . . . 0040-15
Table 15. Load Plan (Stowage Compartment T4).. . . . . . . . 0040-16
CHAPTER 3 TROUBLESHOOTING PROCEDURES
0041 Troubleshooting Instructions Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0041
0042 Operator Level Troubleshooting Fault Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0042
Table 1. Operator Level Troubleshooting Fault Index.. . . . . . 0042-1
0043 Field Level Troubleshooting Fault Index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0043
Table 1. Field Level Troubleshooting Fault Index. . . . . . . . . . 0043-1
OPERATOR TROUBLESHOOTING
0044 24-Volt Battery Charger Does Not Operate. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0044
0045 CHECK FOR OPEN COMPARTMENT DOOR WHEN LIGHT IS ON
Indicator Flashes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0045
0046 Streamlight Battery Charger(s) Does Not Charge Batteries . . . . . . . . . . . . . . . . . . . . WP 0046
0047 Foam System Does Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0047
0048 Pressure Governor Control Displays WARNING! or CAUTION! . . . . . . . . . . . . . . . . . WP 0048
0049 Pressure Governor Controls Do Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0049
0050 Pump Does Not Prime. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0050
0051 Pump Loses Prime or Pressure Governor Displays LOW SUPPLY orPRESET NOT MET, and Pump Returns to Idle Mode . . . . . . . . . . . . . . . . . . . . . . . . WP 0051
0052 Drain Valves or Main Inlet Cap Leaking During Pumping Operations. . . . . . . . . . . . . WP 0052
0053 Handheld Radio Battery Charger(s) Does Not Charge Batteries . . . . . . . . . . . . . . . . WP 0053
0054 Scene Lights, Step Lights, Cab Dome Lights, Clearance Lights, and Stowage
Compartment Lights or Warning Lights Do Not Operate. . . . . . . . . . . . . . . . . . . . . . . WP 0054
0055 Discharges Have Abnormal Water Stream . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0055
FIELD LEVEL TROUBLESHOOTING
FIRE PUMP SYSTEM
0056 Hydraulic Heat Exchanger Fan(s) Do Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0056
FOAM PROPORTIONER SYSTEM
0057 Foam Not Delivered From All Systems (Bumper Turret, Under Truck Nozzles,
and Manual Metering Controls) or System Does Not Shut Off . . . . . . . . . . . . . . . . . . WP 0057
0058 Foam Not Delivered From Bumper Turret . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0058
0059 Foam Not Delivered From Under Truck Nozzles. . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0059
0060 Foam Not Delivered When Manual Metering Control Is Operated . . . . . . . . . . . . . . . WP 0060
TABLE OF CONTENTS (CONTINUED)
WP Sequence No
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
22/211
TM 9-2320-328-13&P-1
viii
DRAFT
0061 Foam System Cannot Be Flushed . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0061
0062 Foam Tank Level Indicator Gauge Does Not Operate Properly. . . . . . . . . . . . . . . . . WP 0062
WATER TANK ASSEMBLY
0063 Bumper Turret Does Not Operate Properly When Selected. . . . . . . . . . . . . . . . . . . . WP 0063
0064 Direct Tank Fill Valve Does Not Operate Properly (Auto or Manual Mode) . . . . . . . . WP 0064
0065 Driver Side Auxiliary Inlet Valve Does Not Operate Properly . . . . . . . . . . . . . . . . . . . WP 0065
0066 Hose Reel Rewind Control Does Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0066
0067 Hose Reel Discharge Valve Does Not Operate When Selected . . . . . . . . . . . . . . . . WP 0067
0068 No. 1 Driver Side Discharge Valve Does Not Operate Properly. . . . . . . . . . . . . . . . . WP 0068
0069 No. 2 Passenger Side Discharge Valve Does Not Operate Properly . . . . . . . . . . . . . WP 0069
0070 Passenger Side Auxiliary Inlet Valve Does Not Operate Properly . . . . . . . . . . . . . . . WP 0070
0071 Pump Cooler Valve Does Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0071
0072 Pressure Governor Controls Do Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . . WP 0072
0073 Pump Priming System Does Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0073
0074 System Will Not Build or Hold Pressure During Blow Out Procedure . . . . . . . . . . . . WP 0074
0075 Tank Fill & Re-Circulating Line Valve Does Not Operate Properly. . . . . . . . . . . . . . . WP 0075
0076 Tank-To-Pump Valve Does Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0076
0077 Under Truck Nozzles Do Not Operate When Selected . . . . . . . . . . . . . . . . . . . . . . . WP 0077
0078 Water Pump Is Noisy . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0078
0079 Water PUMP PTO Does Not Engage When Selected . . . . . . . . . . . . . . . . . . . . . . . . WP 0079
0080 Water Tank Drain Valve Does Not Operate When Selected . . . . . . . . . . . . . . . . . . . WP 0080
0081 Water Tank Level Indicator Gauge Does Not Operate Properly . . . . . . . . . . . . . . . . WP 0081
0082 Water Pump Input Pressure Low or Pressure Governor Displays
CAVITATION, LOW SUPPLY Pressure, and Pump Returns to Idle Mode . . . . . . . . WP 0082
0083 Water Pump Is Overheating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0083
0084 Water Pump Output Pressure Low or Pressure Governor Displays
PRESET NOT MET, and Pump Returns to Idle Mode . . . . . . . . . . . . . . . . . . . . . . . . WP 0084
0085 Windshield Deluge System Does Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . WP 0085
INSTRUMENT HOUSING ASSEMBLY
0086 Cab Switch Backlighting Does Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0086
0087 Direct Tank Fill AUTO Indicator Does Not Illuminate (Pump Operators Panel). . . . . WP 0087
0088 Direct Tank Fill OPEN Indicator Does Not Illuminate (Pump Operators Panel) . . . . WP 0088
TABLE OF CONTENTS (CONTINUED)
WP Sequence No.
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
23/211
TM 9-2320-328-13&P-1
ix
DRAFT
0089 CHECK FOR OPEN COMPARTMENT DOOR WHEN LIGHT IS ON Indicator
Does Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0089
0090 FOAM FLUSH Indicator Does Not Illuminate (Pump Operator's Panel) . . . . . . . . . . . WP 0090
0091 FOAM SYSTEM Indicator Does Not Illuminate (Cab) . . . . . . . . . . . . . . . . . . . . . . . . . WP 0091
0092 FOAM SYSTEM Indicator Does Not Illuminate (Pump Operator's Panel). . . . . . . . . . WP 0092
0093 Hose REEL DISCHARGE Valve Indicator Does Not Illuminate
(Pump Operator's Panel) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0093
0094 PUMP COOLER Indicator Does Not Illuminate (Cab). . . . . . . . . . . . . . . . . . . . . . . . . WP 0094
0095 PUMP COOLER Indicator Does Not Illuminate (Pump Operator's Panel) . . . . . . . . . WP 0095
0096 PUMP PTO ENGAGED Indicator Does Not Illuminate (Cab) . . . . . . . . . . . . . . . . . . . WP 0096
0097 PUMP HOT Audio Alarm or Indicator Does Not Operate Properly
(Pump Operator's Panel) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0097
0098 WATER TANK DRAIN Indicator Does Not Illuminate (Pump Operator's Panel) . . . . . WP 0098
0099 TANK TO PUMP Indicator Does Not Illuminate (Cab). . . . . . . . . . . . . . . . . . . . . . . . . WP 0099
0100 TANK TO PUMP Indicator Does Not Illuminate (Pump Operator's Panel) . . . . . . . . . WP 0100
0101 UNDER TRUCK NOZZLES Indicator Does Not Illuminate (CAB). . . . . . . . . . . . . . . . WP 0101
WARNING LIGHT ASSEMBLY
0102 Warning Lights (All) Do Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0102
0103 Warning Lights (Front and Rear Lower) Do Not Operate . . . . . . . . . . . . . . . . . . . . . . WP 0103
0104 Warning Lights (Overhead Beacon) Do Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . WP 0104
0105 Warning Lights (Cab Roof Lightbar) Do Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . WP 0105
0106 Warning Lights (Side) Do Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0106
0107 Warning Lights (Upper Rear) Do Not Operate. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0107
SPOTLIGHTS
0108 Driver Side Scene Light(s) Does Not Operate. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0108
0109 Step (Hose Bed) Light(s) Does Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0109
0110 Passenger Side Scene Light(s) Does Not Operate . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0110
0111 Rear Scene Light(s) Does Not Operate. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0111
DOME AND ENGINE LIGHT ASSEMBLY
0112 Cab Dome Light(s) Does Not Operate. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0112
ALPHABETICAL INDEX . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . INDEX-1
TABLE OF CONTENTS (CONTINUED)
WP Sequence No
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/http://0.0.0.0/8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
24/211
TM 9-2320-328-13&P-1
x
DRAFT
VOLUME 2
CHAPTER 3 TROUBLESHOOTING PROCEDURES (CONTINUED)
MISCELLANEOUS ELECTRICAL COMPONENTS
0113 12-Volt Handheld Radio Charger(s) Does Not Operate . . . . . . . . . . . . . . . . . . . . . . . WP 0113
0114 12-Volt Streamlight Charger(s) Does Not Operate. . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0114
0115 24-Volt Battery Charger Does Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . . . . WP 0115
0116 Clearance and/or Directional Light(s) Does Not Operate . . . . . . . . . . . . . . . . . . . . . . WP 0116
0117 Driver Side Stowage Compartment Striplight(s) Does Not Operate. . . . . . . . . . . . . . WP 0117
0118 Foam/Water Level Gauge(s) Does Not Illuminate . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0118
0119 Two-Way Radio Does Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0119
0120 Intercom and Headsets Do Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0120
0121 Passenger Side Stowage Compartment Striplight(s) Does Not Operate . . . . . . . . . . WP 0121
0122 Pump House or Pump Operators Panel Striplight(s) Does Not Operate. . . . . . . . . . WP 0122
0123 Rear Step Buzzer Audio Alarm Does Not Operate. . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0123
0124 SINCGARS Do Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0124
0125 Siren Does Not Operate Properly. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0125
0126 Shoreline Inlet Receptacle Does Not Operate Properly . . . . . . . . . . . . . . . . . . . . . . . WP 0126
HEATER, VEHICULAR COMPARTMENT
0127 Pump House Heater Does Not Operate Properly. . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0127
CHAPTER 4 PREVENTIVE MAINTENANCE CHECKS AND SERVICES (PMCS)
0128 Preventive Maintenance Checks and Services (PMCS) Introduction. . . . . . . . . . . . . WP 0128
0129 Preventive Maintenance Checks and Services (PMCS), Including
Lubrication Instructions. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0129
Table 1. Preventive Maintenance Checks and Services. . . . 0129-2
Table 2. Lubricating Chart. . . . . . . . . . . . . . . . . . . . . . . . . . 0129-35
CHAPTER 5 MAINTENANCE INSTRUCTIONS
0130 Maintenance General Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0130
Table 1. Tire Pressures. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 0130-2
Table 2. Recommended Flats Rotation. . . . . . . . . . . . . . . . 0130-10
Figure 1. General Tightening Sequences. . . . . . . . . . . . . . 0130-11
TABLE OF CONTENTS (CONTINUED)
WP Sequence No.
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
25/211
TM 9-2320-328-13&P-1
xi
DRAFT
ADJUSTMENTS AND ALIGNMENTS
0131 Stowage Compartment Door Latch Striker Adjustment . . . . . . . . . . . . . . . . . . . . . . . . WP 0131
0132 Bumper Turret Adjustment . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0132
FIRE PUMP SYSTEM
0133 Hydraulic Heat Exchanger Fan(s) Switch Replacement . . . . . . . . . . . . . . . . . . . . . . . WP 0133
0134 Hydraulic Heat Exchanger Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0134
0135 Hydraulic Heat Exchanger Bottom Shroud Panel Replacement . . . . . . . . . . . . . . . . . WP 0135
0136 Hydraulic Heat Exchanger Fan(s) Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0136
0137 Hydraulic Heat Exchanger Shroud Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0137
0138 Hydraulic Hose Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0138
Table 1. Hydraulic Reservoir Hoses. . . . . . . . . . . . . . . . . . . . 0138-3
Table 2. Hydrostatic Charge Pump Hoses. . . . . . . . . . . . . . . 0138-4
Table 3. Hydraulic Override Manifold Hoses.. . . . . . . . . . . . . 0138-5
Table 4. Hydraulic Oil Filter Base Hoses. . . . . . . . . . . . . . . . 0138-6
Table 5. Hydrostatic Pump Motor. . . . . . . . . . . . . . . . . . . . . . 0138-6
Table 6. Hydraulic Pressure Control Hoses. . . . . . . . . . . . . . 0138-7
Table 7. Hydraulic Heat Exchanger.. . . . . . . . . . . . . . . . . . . . 0138-8
0139 Hydraulic Oil Drain Mounting Bracket Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0139
0140 Hydraulic Oil Filter Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0140
0141 Hydraulic Oil Filter Base Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0141
0142 Hydraulic Override Manifold Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0142
0143 Hydraulic Pressure Control Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0143
0144 Hydraulic Reservoir Breather Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0144
0145 Hydraulic Reservoir Drain/Fill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0145
0146 Hydraulic Reservoir Fluid Level Gauge Replacement. . . . . . . . . . . . . . . . . . . . . . . . . WP 0146
0147 Hydraulic Reservoir Fluid Level Switch Replacement . . . . . . . . . . . . . . . . . . . . . . . . . WP 0147
0148 Hydraulic Reservoir and Bracket Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0148
0149 Hydraulic Reservoir Strainer Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0149
0150 Hydraulic Reservoir Temperature Sensor Replacement . . . . . . . . . . . . . . . . . . . . . . . WP 0150
0151 Hydrostatic Pump Motor Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0151
0152 Hydrostatic Charge Pump Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0152
0153 Power Take Off (PTO) Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0153
TABLE OF CONTENTS (CONTINUED)
WP Sequence No
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
26/211
TM 9-2320-328-13&P-1
xii
DRAFT
0154 Power Take Off (PTO) Drive Shaft Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0154
0155 Power Take Off (PTO) Solenoid and Pressure Switch Replacement. . . . . . . . . . . . . WP 0155
0156 Water Pump Dipstick Assembly Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0156
0157 Water Pump Gear Case Drain/Fill . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0157
0158 Water Pump Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0158
RELIEF VALVE ASSEMBLY
0159 Passenger Side Auxiliary Inlet Drain Valve Replacement . . . . . . . . . . . . . . . . . . . . . WP 0159
0160 Driver Side Auxiliary Inlet Drain Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . WP 0160
0161 No. 1 Driver Side Discharge Drain Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . WP 0161
0162 No. 2 Passenger Side Discharge Drain Valve Replacement . . . . . . . . . . . . . . . . . . . WP 0162
0163 Thermal Relief Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0163
PRIMER PUMP ASSEMBLY
0164 Manual Primer Handle Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0164
0165 Primer Pump Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0165
0166 Primer Tank and Bracket Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0166
0167 Primer Valve Cable Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0167
0168 Primer Valve Control Solenoid Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0168
0169 Primer Valve Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0169
DRAIN VALVE ASSEMBLY
0170 Bumper Turret Auto Drain Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0170
0171 Foam Tank Drain Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0171
0172 Water Tank Drain Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0172
FOAM SYSTEM ASSEMBLY
0173 Bumper Turret Foam Metering Valve and Orifice Replacement. . . . . . . . . . . . . . . . . WP 0173
0174 Under Truck Nozzles Foam Metering Valve and Orifice Replacement . . . . . . . . . . . WP 0174
0175 Foam Tank Level Probe Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0175
0176 Foam System Shutoff Valve Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0176
0177 Foam System Eductor Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0177
0178 Foam System Eductor Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0178
0179 Foam System Flush Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0179
0180 Foam System Inlet Check Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0180
0181 Foam System Manual Metering Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . WP 0181
TABLE OF CONTENTS (CONTINUED)
WP Sequence No.
Page No.- - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - - -
8/14/2019 TM 9-2320-328-13P-1 HEWATT M1158 PART 1
27/211
TM 9-2320-328-13&P-1
xiii
DRAFT
0182 Foam System Service Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0182
0183 Foam System Strainer(s) Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0183
0184 Foam Tank Pressure/Vacuum/Vent Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0184
0185 Foam Tank Fill Port Extension and Cover Replacement. . . . . . . . . . . . . . . . . . . . . . . WP 0185
WATER TANK ASSEMBLY
0186 Inlet Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0186
0187 Tank-To-Pump Check Valve Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0187
0188 Manual Bray Dump Valve(s) Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0188
0189 Foam/Water Tank Level Probe Cover Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . WP 0189
0190 Water Tank Level Probe Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0190
0191 Water Tank Fill & Re-Circulating Line Valve Replacement . . . . . . . . . . . . . . . . . . . . . WP 0191
0192 Water Tank Vent Fill Tower Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0192
0193 Water Tank Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0193
0194 Water Tank Cradle Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0194
INSTRUMENT PANEL ASSEMBLY
0195 CHECK FOR OPEN COMPARTMENT DOOR WHEN LIGHT IS ON
Indicator Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0195
0196 Warning Light and CHECK FOR OPEN COMPARTMENT DOOR
WHEN LIGHT IS ON Flasher Unit(s) Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0196
0197 Cab Pressure Governor Control Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0197
0198 Cab Panel Indicator Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0198
0199 Cab Rocker Switch Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0199
0200 Cab Water and/or Foam Level Gauge(s) Replacement . . . . . . . . . . . . . . . . . . . . . . . WP 0200
0201 Cab 1-2-3 Signal Indicator Lamp Holder Replacement . . . . . . . . . . . . . . . . . . . . . . . . WP 0201
0202 Cab 1-2-3 Signal Indicator Lamp Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0202
0203 Warning Buzzer (Cab and Pump Operator's Panel) Replacement . . . . . . . . . . . . . . . WP 0203
0204 Cab Instrument Panel Assembly Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0204
0205 Cab Instrument Panel Replacement . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0205
0206 Pump Operator's Panel Cover Replacement. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0206
0207 Pump Operator's Panel Open/Close . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . WP 0207
0208 Pump Operator's Panel Replacement . . . . . . . . . . . . . .