Technical Bulletin Listing 2007 - · PDF fileU140E / U240E 1087 5 Valve Body Exploded View June ... Technical Bulletin Listing 2007 ... A4BF2 1145 1 Check Ball Locations 62TE

Copyright © 2007ATRA. All Rights Reserved. ATRA > Page 1 of 3

Technical Bulletin Listing 2007

December, 2007

Transmission Bulletin # # Pages SubjectJanuary U140E, U140F 829A 2 Sprag RotationV4A51 1054 1 No Power Above 3500 RPM4T60E 1055 1 Neutral/Shudder During the 1-2 ShiftZF5HP24 1056 1 Intermittent Harsh ShiftsU140E, U140F 1057 1 Harsh/Soft Shifts and/or Harsh/Soft EngagementsA4RA, B4RA, M4RA 1058 2 DTC P0740, Honda DTC 40U140E, U140F 1059 1 No 4th, No TCCBMXA 1060 1 Feed Pipe ID and Location01M 1061 2 3-4 Neutral5R55N/S/W 1062 1 Skips 2nd or 5th Gear When Cold

February 4F27E 1063 1 Soft Shifts w/ Low Line Pressure and No Line Rise4T45E 1064 2 2006 Interim Changes6L80 1065 2 4-5 Erratic Shift, DTC P0756BW 4405 T-Case 1066 1 No Reverse, Grinds in Reverse and/or on

Deceleration6L80 1067 2 Erratic Shifts, Engine Stalls All GM 1068 3 VIN Systems722.6 1069 4 SpecificationsandPartNumbersHonda/ Acura 1070 1 P0715 Honda DTC 154L80E 1071 1 Stall or Surge at Idle5R55N/S/W 1062A 1 Skips 2nd or 5th Gear When ColdTorqShift 1033A 1 TCC Slip After the Rebuild

March 6HP26 1072 1 Fluid Drain and Fill ProcedureAX4N, 4F50N, AX4S 1073 1 Erratic Fluid Level, Possible Fluid Leak5L50E 1074 1 Fluid Check and Fill ProceduresBW 4405 T-Case 1075 1 4X4 Inop, Possible CodesBW 4405 T-Case 1076 1 Shudder, Binds in turns, Erratic OperationA340 1077 1 Solenoid ID and Description4T65E 1078 1 3rd Gear Starts, binds in Man 201M 1079 1 TCC Cycling4F27E 1080 1 Low One-Way Clutch Retainer5R55E 777A 1 2-3 Flare (Revised)

Technical Bulletin Listing

Copyright © 2007 ATRA. All Rights Reserved.

MayAX4S, AX4N 675A 1 No 3rd, No Engine Breaking in Maunal 3rdAX4S, AX4N 1088 1 Broken Stator Support ShaftFront 4X4 Axle 1089 1 Vibration from the 4X4 System01M 1090 1 Converter Bushing Design4F27E 1091 1 Trans Shifts to Neutral on the 3-4 Shift, Code P0750CD4E 1092 1 PumpshaftIdentification5R55N/S/W 1093 1 Valve Body Bolt Installation Procedure 4R70W/AODE 1094 1 TCC Slip, Code P07414T65E 1095 1 Erratic Shift, 1-2 Shudder

ATRA> Page 2 of 3

April 5R55N/S/W 1062B 1 Skips 2nd and 5th Gear when Cold4T60E 1055A 1 Neutral / Shudder During the 1-2 ShiftTorqshift 1081 1 Binds in Reverse, Second Gear Starts Poss. DTC’s4L60E/65E/70E 1082 2 DTC P0757, Poor PerformanceEC8 1083 1 Intermittent Forward722.6/NAG1 1084 4 SolenoidOperationandIdentificationAll Honda 1085 2 Manual Code Retrieval450-43LE 1086 1 Replacement Part #’s for the ElectronicsU140E / U240E 1087 5 Valve Body Exploded View

June4L60E,4L80E 606A 1 SESLightOn,IntermittentMisfireand/orSurgeF4A40/50 Series 1096 1 Clutch Location Chart722.6/NAG 1 1097 2 Valve Body Exploded ViewA540E/H, A541E 1098 10 Valve Body Expoloded Views5L50E 1099 1 TCC Surge, Shudder or Chuggle4T65E 1100 1 Fluid Leaking after the Overhaul4T65E 1101 1 DTC P0742 and/or P02761 or Just P2764 Ford, GM, Chrysler, Toyota 1102 1 Resetting the Shift AdaptsJuly4T80E 1103 1 Installation of the Freeting RingU140/U240 1104 1 Clutch Application ChartJF506E(Jatco FWD 5-Speed) 1105 1 Rebuilding Procedure02E 1106 1 SolenoidLocationandIdentification02E 1107 1 Fail SafeHonda & Acura 1108 1 Erratic Shifting, Bind-ups, Binds on the 1-2 shift,

Lugs the Engine4T65E 1109 1 Input Speed Sensor Application Honda & Acura 1110 1 Axiom Pressure Switch Application4F27E 1111 1 Air Check Procedures

2007

Copyright © 2007ATRA. All Rights Reserved.

October4L60/65/70E 1129 1 Input carrier, Reaction Carrier Shaft, and Bearing

changesLCT 1000 1130 1 Harsh Down Shifts, Harsh Garage Shifts LCT 1000 1131 1 Lack of Stall Speed in 4WD RangeLCT 1000 1132 1 Flare when Accelerating from a Stop09G 6 Speed 1133 1 Oil Fill Procedure5L40E 1134 1 Forward Sprag45RFE 1135 1 Soft Shifts or Flares4R44/55E, 5R44/55E 1136 1 Wrong Gear Starts

ATRA> Page 3 of 3

Technical Bulletin Listing 2007

November4T65E 732B 1 Updated Transmission Fluid Pressure SwitchA4BF1 1137 1 Reoccurring PCS Circuit Code 748F4A21-1, F4A33, F4A42, A4AF3, A4BF1 1138 1 Harsh 4-3 Down Shift on Decel to a StopA4AF1/2, F4A32 1139 1 DTC 1613 or 1614 Stored in the TCM4R70/75W/E 1140 1 Redesigned Sun Shell096, 01M 1141 1 No PressureAllison LCT 1000 1142 1 Leak at the Vent41TE 1143 1 Scanner Access

AugustHonda 1112 1 Erratic 1-2 Shift and/or Stacked 2-3 Shift450-43LE 1113 1 PressureProceduresandSpecifications722.6 1114 2 Sprag RotationsHonda 1115 1 Gear Whine in 1st, 2nd, and 3rd4R100/E4OD 1116 1 Shift 1-2 with No 3rd Gear4L80E 1117 1 Planetary Damage, Pump InterchangeAW50-42LE 1118 1 No Reverse4F27E 1119 2 Neutrals on the 3-4 Shift, DTC P07504R44/55E 1120 2 TCCModification

September5R55S/W 1121 2 No or Delayed EngagementZF5HP19 1122 1 Solenoid ID R4A51 and V4A51 1123 1 Manual Control Shaft Pin (Location and Size)R4A51 and V4A51 1124 1 Accumulator Spring and LocationsA541 1125 1 Two Vibration Clip LocationsA541 1126 1 TransmissionSolenoidIdentificationF4A41/42/51 1127 1 Low Line Pressure46/47RE 1128 6 Lock-up and/or 4th Gear Hunt, No Codes

DecemberA650 1144 1 Clutch and Band OperationA4AF3, A4BF2 1145 1 Check Ball Locations62TE 1146 3 Pre-Diagnostic Troubleshooting Procedures4T40/45E 1147 8 Updates: 2004 Model YrA4AF3, A4BF2 1148 2 Fail End Clutch Hub Bearing

Technical Bulletin # 1144

Copyright © 2007 ATRA. All Rights Reserved. RS> Page 1 of 1

Transmission:Subject:

Application:Issue Date:

A650Clutch and Band Application ChartToyota/Lexus

December, 2007

A650 Clutch and Band Operation


Copyright © 2007 ATRA. All Rights Reserved. DS> Page 1 of 1



A4AF3, A4BF2Checkball LocationHyundai

December, 2007

A4AF3, A4BF2

These graphics show the proper check ball locations for these units. Pay attention to the #1 check ball with the spring.

Check Ball Locations


Copyright © 2007 ATRA. All Rights Reserved. RS> Page 1 of 3



62TE

Pre-Diagnostic Troubleshooting ProcedureChrysler

December, 2007

62TEPre-Diagnostic Troubleshooting Procedure



RS> Page 2 of 3

dure



RS > Page 3 of 3


Copyright © 2007 ATRA. All Rights Reserved. ATRA> Page 1 of 8



4T40E/4T45EUpdates2004 Model Year Changes

December, 2007

4T40E/4T45EUpdates: 2004 Model Year Changes for the 4T40E and 4T45E Transmissions

NOTE: These parts will NOT interchange with earlier designed units



ATRA> Page 2 of 8

New Spacer Plate for the Electronic Range Selector Mode Models (Z body Malibu Classic)



ATRA > Page 3 of 8

New Valve Body Assembly, TCC Control Valve



ATRA> Page 4 of 8

New Valve Body Assembly, TCC Control Valve (continued)

New Hydrophobic Filter/Vent and Filler Cap with Case Baffle



ATRA > Page 5 of 8

Decontented Transmission Fluid Pressure (TFP)


Copyright © 2007 ATRA. All Rights Reserved.ATRA > Page 6 of 8

New NSBU (Neutral Safety Back Up) Switch

New PCS Solenoid



New Drive Chain

New Washers for the Input Carrier



New Pump Needle Bearing


Copyright © 2007 ATRA. All Rights Reserved. ATRA> Page 1 of 2



A4AF3, A4BF2Failed End Clutch Hub BearingHyundai

December, 2007

A4AF3, A4BF2Failed End Clutch Hub Bearing

The Shim part is available from your parts suppliers



ATRA > Page 2 of 2

lbs

lbs

lbs

lbs

lbs

lbs

lbs

lbs

lbs

lbs

Documents

Technical Bulletin Listing 2007 - · PDF fileU140E / U240E 1087 5 Valve Body Exploded View June ... Technical Bulletin Listing 2007 ... A4BF2 1145 1 Check Ball Locations 62TE