Embed Size (px)
DESCRIPTION
Product Tanker BP cleaning Guide
Citation preview
7/21/2019 Tank Cleaning Guide - BP New 2006
http://slidepdf.com/reader/full/tank-cleaning-guide-bp-new-2006 1/1
BP Tank Cleaning Guide
N a p
h t h a
/ C l e a n
C o
n d e n s a
t e s
/ L D F
A v g a s
M T B E / E T B E / T A M E / E t h a n o
l / M e
t h a n o
l
L e a
d e
d M o
t o r
S p
i r i t
U n
l e a
d e
d M o
t o r
S p i r i t
S u
l p h u r
F r e e
M o
t o r
S p
i r i t
S o
l v e n
t s
J e t / A v
i a t i o n
K e r o s e n e s
K e r o s e n e s
( u n
d y e d
)
K e r o s e n e s
( d y e
d )
G a s
O i l ( u n
d y e
d )
G a s
O i l ( d y e
d )
S u
l p h u r
F r e e
D i e s e l
/ U L S D
F A M E / B i o d i e s e
l
C r u
d e
O i l s / D i r t y C o n
d e n s a
t e s
L u
b e
O i l s
W a x
D i s t i l l a t e / V a c u u m
G a s
O i l
A t m o s p
h r i c
R e s
i d u e
H e a v y
/ M e
d i u m
F u
e l O i l
L o w
S u
l p h u r
F u e
l O
i l ( L S F O / L S W R )
L i g h t F u e
l O i l ( L F O )
Naphtha/Clean Condensates/LDF
Avgas
MTBE M M M M M M M M
Ethanol/Methanol M M M M M M M M
Leaded Motor Spirit
Unleaded Motor Spirit
Sulphur Free Motor Spirit
Solvents PM PM PM PM PM PM PM PM D M M M
Jet / Aviation Kerosenes PM PM PM PM PM PM PM PM D M
Kerosenes (undyed) P P P P P
Kerosenes (dyed) P P P P P
Un-dyed Gas Oil P P P P P P P
Dyed Gas Oil P P P P P P P
FAME / Biodiesel M M M M M M M M M M M M M M M
Ultra Low Sulphur Diesel/Gas Oil PM PM PM PM PM PM PM PM M M
Sulphur Free Diesel PM PM PM PM PM PM PM
Crude Oils / Dirty Condensates
Lube Oils PM PM PM PM PM PM PM M LUB
Wax Distillate / Vacuum Gas Oil P P P P P P
Atmospheric Residue P P P P P P
Heavy / Medium Fuel Oil PX PX PX PX P PX
Low Sulphur Fuel Oil (LSFO / LSWR) PX PX PX PX P P
Light Fuel Oil (LFO) PX PX PX PX P P X X X
THIS GUIDE COVERS WHITE OIL CARGOES IN COATED TANKS.
AND BLACK OIL / CRUDE CARGOES IN EITHER COATED OR UNCOATED TANKS.
No washing required - strip and drain well
Refer Notes: 1 & 2
Wash tanks with COLD sea water until tank is clean cargo may be loaded directly on top without washing
Refer Notes 1, 2 & 3
Tanks that have been washed for the carriage of these
Wash tanks with HOT sea water until tank is clean. products must have a final wash with fresh water.
Refer Notes 1, 2 & 3 Tank and lines are then to be blown and drained free of water.
To ensure minimum grade to grade admixture, tanks to be
Product NOT to be loaded unless specific instructions LUB stripped dry, pump column and deck lines to be blown and
have been issued by BP Head Office drained. Tanks to be visually inspected to ensure min ROB
Notes: 1. Tanks to be stripped dry such that any liquid ROB is confined to the pump well - or better.
2. Pump columns, deck lines, drops etc are to be blown clear and drained free of all product and water.
3. Deck lines, loading drops and cross over lines must be thoroughly washed and drained.
4. MTBE/Methanol/Ethanol (oxygenates) Are water miscible, introduction of water into designated tanks should be avoided.
5. These tank cleaning guidelines are guidelines only and not to be regarded as BP instructions to inspectors
X If ROB is less than 0.1%, and purging (if required) is effective,
M Tanks to be mopped or educted DRY
P Tanks to be purged to below 2% Hydrocarbon by volume
Non IG Vessels should be 'Gas Free'
Previous
Cargo
Cargo to
be Loaded
