SERVICE MANUAL - Fracassi · TK-7150 3 5-2. Radio location Select a convenient location for your control station radio which is as close as practical to the antenna cable entry point

© 2002-10 PRINTED IN JAPANB51-8633-00 (N) 843

VHF FM TRANSCEIVER

TK-7150SERVICE MANUAL

Microphone(T91-0621-15)

Cabinet(A01-2185-12)

Panel assy(A62-1037-03)

Key top(K29-9222-02)

Knob(K29-9221-03) x 2

CONTENTSGENERAL .................................................. 2

SYSTEM SET-UP ...................................... 3

OPERATING FEATURES .......................... 4

REALIGNMENT ......................................... 5

INSTALLATION ......................................... 7

CIRCUIT DESCRIPTION .......................... 12

SEMICONDUCTOR DATA ...................... 16

COMPONENTS DESCRIPTION .............. 20

PARTS LIST ............................................. 22

EXPLODED VIEW.................................... 32

PACKING ................................................. 33

ADJUSTMENT ........................................ 34

PC BOARD

DISPLAY UNIT (X54-3400-10) ............ 45

TX-RX UNIT (X57-6570-10) ................ 49

SCHEMATIC DIAGRAM.......................... 55

BLOCK DIAGRAM ................................... 63

WIRING.................................................... 65

TERMINAL FUNCTION ........................... 66

OPTIONS ................................................. 68

SPECIFICATIONS .................................... 69

TK-7150

2

INTRODUCTION

SCOPE OF THIS MANUALThis manual is intended for use by experienced techni-

cians familiar with similar types of commercial grade commu-nications equipment. It contains all required service informa-tion for the equipment and is current as of this publicationdata. Changes which may occur after publication are coveredby either Service Bulletins or Manual Revisions. These areissued as required.

ORDERING REPLACEMENT PARTSWhen ordering replacement parts or equipment informa-

tion, the full part identification number should be included.This applies to all parts : components, kits, and chassis. If thepart number is not known, include the chassis or kit numberof which it is a part, and a sufficient description of the re-quired component for proper identification.

PERSONNEL SAFETYThe following precautions are recommended for person-

nel safety :• DO NOT transmit if someone is within two feet (0.6

meter) of the antenna.• DO NOT transmit until all RF connectors are verified se-

cure and any open connectors are properly terminated.• SHUT OFF and DO NOT operate this equipment near

electrical blasting caps or in an explosive atmosphere.• All equipment should be properly grounded before power-

up for safe operation.• This equipment should be serviced by a qualified techni-

cians only.

PRE-INSTALLATION CONSIDERNATIONS

1. UNPACKINGUnpack the radio from its shipping container and check for

accessory items. If any item is missing, please contactKENWOOD immediately.

2. LICENSING REQUIREMENTSFederal regulations require a station license for each radio

installation (mobile or base) be obtained by the equipmentowner. The licensee is responsible for ensuring transmitterpower, frequency, and deviation are within the limits permit-ted by the station license.

Transmitter adjustments may be performed only by a li-censed technician holding an FCC first, second or generalclass commercial radiotelephone operator’s license. There isno license required to install or operate the radio.

3. PRE-INSTALLATION CHECKOUT

3-1. IntroductionEach radio is adjusted and tested before shipment. How-

ever, it is recommended that receiver and transmitter opera-tion be checked for proper operation before installation.

3-2. TestingThe radio should be tested complete with all cabling and

accessories as they will be connected in the final installation.Transmitter frequency, deviation, and power output shouldbe checked, as should receiver sensitivity, squelch operation,and audio output. QT equipment operation should be veri-fied.

4. PLANNING THE INSTALLATION

4-1. GeneralInspect the vehicle and determine how and where the ra-

dio antenna and accessories will be mounted.Plan cable runs for protection against pinching or crushing

wiring, and radio installation to prevent overheating.

4-2. AntennaThe favored location for an antenna is in the center of a

large, flat conductive area, usually at the roof center. Thetrunk lid is preferred, bond the trunk lid and vehicle chassisusing ground straps to ensure the lid is at chassis ground.

4-3. RadioThe universal mount bracket allows the radio to be

mounted in a variety of ways. Be sure the mounting surfaceis adequate to support the radio’s weight. Allow sufficientspace around the radio for air cooling. Position the radioclose enough to the vehicle operator to permit easy access tothe controls when driving.

4-4. DC Power and wiring1. This radio may be installed in negative ground electrical

systems only. Reverse polarity will cause the cable fuseto blow. Check the vehicle ground polarity before installa-tion to prevent wasted time and effort.

2. Connect the positive power lead directly to the vehiclebattery positive terminal. Connecting the Positive lead toany other positive voltage source in the vehicle is not rec-ommended.

CAUTIONIf DC power is to be controlled by the vehicle ignition switch,a switching relay should be used to switch the positive powerlead. The vehicle ignition switch then controls DC to the relaycoil.

3. Connect the ground lead directly to the battery negativeterminal.

4. The cable provided with the radio is sufficient to handlethe maximum radio current demand. If the cable must beextended, be sure the additional wire is sufficient for thecurrent to be carried and length of the added lead.

5. INSTALLATION PLANNING – CONTROL STATIONS

5-1. Antenna systemControl station. The antenna system selection depends

on many factors and is beyond the scope of this manual.Your KENWOOD dealer can help you select an antenna sys-tem that will best serve your particular needs.

GENERAL

TK-7150

3

5-2. Radio locationSelect a convenient location for your control station radio

which is as close as practical to the antenna cable entry point.Secondly, use your system’s power supply (which suppliesthe voltage and current required for your system). Make suresufficient air can flow around the radio and power supply toallow adequate cooling.

Merchandise received

License and frequencyallocated by FCC

Choose the type of transceiverFrequency range RF power Type

136~174MHz 50W TK-7150 K

Are you usingthe remote kit?

YESKRK-9

Control cable KCT-22M : 8 feet M2 : 17 feetM3 : 25 feet

Are you usingthe key label? Supplied key label

Are you usingthe voice scrambler/

ANI?Modified of control unit

Are you usingthe ignition sense

cable?KCT-18

Are you usingthe noise-canceling micro-

phone?

KMC-28A

Supplied microphone

Delivery

Transceiver programming

DC power cableSupplied cable or

KCT-23 M : 10 feetKCT-23 M3 : 23 feet

Are you usingthe external speaker?

Are you usingthe keypad microphone?

YES

YES

YES

External speaker KES-5YES

YES

KMC-27AYES

NO

NO

NO

NO

NO

NO

NO

See page 5. A personal computer (IBM PC or compatible), programming interface (KPG-46), and programming software (KPG-79D) are required for programming.

See page 8.

See page 7.

See page 9.

See page 7.

See page 7.

DC power supply KPS-10A

Desk top microphone KMC-9C

SERVICEThis radio is designed for easy servicing. Refer to the

schematic diagrams, printed circuit board views, and align-ment procedures contained in this manual.

GENERAL / SYSTEM SET-UP

SYSTEM SET-UP

TK-7150

4

OPERATING FEATURES

1. Controls and Functions

1-1. Front Panel

q w e r

!0t y u oi !1 !2

1-2. Microphone

!3

q Volume ControlRotate to adjust the volume level. Clockwise increasesthe volume and counterclockwise decreases the volume.

w Display(See right.)

e SelectorRotate to select a Zone or CH/GID (channel/group ID).Clockwise increases the Zone / CH/GID and counterclock-wise decreases the Zone / CH/GID. The default setting isCH/GID Up/Down.

r (Power) switchPress to switch the transceiver ON. Press and hold forapproximately 1 second to switch the transceiver OFF.

t Microphone JackInsert the microphone plug into this jack.

y PF1 KeyPress this key to activate its programmable auxiliary func-tion. The default setting is Zone Up.

u PF2 KeyPress this key to activate its programmable auxiliary func-tion. The default setting is Zone Down.

i PF3 KeyPress this key to activate its programmable auxiliary func-tion. The default setting is None.

o PF4 KeyPress this key to activate its programmable auxiliary func-tion. The default setting is None.

!0 PF5 KeyPress this key to activate its programmable auxiliary func-tion. The default setting is None.

!1 PF6 KeyPress this key to activate its programmable auxiliary func-tion. The default setting is None.

!2 TX / BUSY LEDsThe TX LED lights red while transmitting. In ConventionalGroups, the BUSY LED lights green while receiving.

!3 PTT switchTo transmit, press and hold this switch, then speak intothe microphone. Release to receive.

1-3. Display

Indicator Description

Displays the zone, group ID, and channel

numbers. Also displays various functions

which have been programmed by your dealer.

CALLAppears when the squelch opens during a

2-Tone or DTMF call.

MONAppears when the key programmed as

Monitor is pressed.

Appears when the selected Zone is added to

(left side) the scan list.

SCN Appears when you are using Scan mode.

SPAppears when you are using an external

speaker.

OPAppears when the optional scrambler board

is installed and activated.

Appears when the selected Channel/Group

(right side) ID is added to the scan list.

AAppears when the auxiliary A function is

activated.

BAppears when the auxiliary B function is

activated.

OSAppears when Operator Selectable Tone is

activated.

Appears when a FleetSync message is

stored in the transceiver memory. Appears

and blinks when a new message is received.

Displays the zone, group ID, and channel

numbers. Your dealer can program the zone,

group ID, and channel names with up to 12

characters, in place of numbers.

1-4. Rear Panel

SCN SP OP OSA BMONCALL

Power inputconnector

6-pin connector(for accessories)

25-pin connector(for accessories)

Antennaconnector

TK-7150

5

REALIGNMENT

1. Modes 3. Panel Test ModeSetting method refer to “ADJUSTMENT”.

4. Panel Tuning ModeSetting method refer to “ADJUSTMENT”.

5. PC Mode

5-1. PrefaceThe transceiver is programmed by using a personal com-

puter, programming interface (KPG-46) and programmingsoftware (KPG-79D).

The programming software can be used with an IBM PCor compatible. Figure 1 shows the setup of an IBM PC forprogramming.

5-2. Connection Procedure1. Connect the transceiver to the personal computer with

the interface cable.2. When the Power switch on, user mode can be entered

immediately. When PC sends command the radio enterPC mode, and “PROGRAM” is displayed on the LCD.When data transmitting from transceiver, the red LED isblinking.When data receiving to transceiver, the green LED is blink-ing.

5-3. KPG-46 Description

(PC programming interface cable : Option)The KPG-46 is required to interface the transceiver to the

computer. It has a circuit in its D-subconnector (25-pin) casethat converts the RS-232C logic level to the TTL level.

The KPG-46 connects the modular microphone jack of thetransceiver to the computers RS-232C serial port.

5-4. Programming Software DescriptionThe KPG-79D programming disk is supplied in 3-1/2” disk

format. The software on this disk allows a user to programthe transceiver radio via programming interface cable (KPG-46).

Mode Function

User mode For normal use.

Panel test mode Used by the dealer to check the funda-

ment characteristics.

Panel tuning mode Used by the dealer to tune the radio.

PC mode Used for communication between the

radio and PC (IBM compatible).

FPU data program- Used to read and write frequency data and

ming mode other features to and from the radio.

PC test mode Used to check the radio using the PC.

This feature is included in the FPU.

See panel tuning.

Firmware program- Used when changing the main program of

ming mode the flash memory.

Clone mode Used to transfer programming data from

one radio to another.

Firmware version Used to confirm the internal firmware

information version.

2. How to Enter Each Mode

Mode Operation

User mode Power ON

Panel test mode [PF1]+Power ON

Panel tuning mode [Panel test mode]+[PF3]

PC mode Received commands from PC

Firmware programming mode [PF2]+Power ON

Checksum display mode [Firmware programming mode]+[PF5]

Clone mode [PF6]+Power ON

Firmware version information [PF3]+Power ON (one second)

User mode

Panel test mode Panel tuning mode

PC mode FPU data programming mode

Firmware program-ming mode

PC test mode PC tuning mode

Checksumdisplay mode

Clone mode

Firmware versioninformation

[PF1]+Power on

[PF6]+Power on

[PF3]+Power on

[PF3]

[PF5]

[PF4]

KPG-46 orKPG-46 +Tuning cable(E30-3383-05)

TK-7150

IBM PC

KPG-79D

Fig. 1

TK-7150

6

5-5. Programming With IBM PCIf data is transferred to the transceiver from an IBM PC

with the KPG-79D, the destination data (basic radio informa-tion) for each set can be modified. Normally, it is not neces-sary to modify the destination data because their values aredetermined automatically when the frequency range (fre-quency type) is set.

The values should be modified only if necessary.Data can be programmed into the flash memory in RS-

232C format via the modular microphone jack.KPG-79D instruction manual parts No. : B62-1588-XX.

6. Firmware Programming Mode

6-1. PrefaceThe TK-7150 uses flash memory to allow it to be easily

upgraded when new features are released in the future.

6-2. Connection ProcedureConnect the TK-7150 to the personal computer (IBM PC or

compatible) with the interface cable (KPG-46). (Connection isthe same as in the PC mode.)

Note :You can only program firmware from the 8-pin micro-

phone connector on the front panel. Using the 25-pin logicinterface on the rear panel will not work.

6-3. Programming1. Start up the programming software (Fpro. exe).2. Set the communications speed (normally, 57600 bps) and

communications port in the configuration item.3. Set the firmware to be updated by file name item.4. Turn ON the transceiver while pressing and holding the

[PF2] key. The transceiver enters Firmware programmingmode and “PROG 57600”. If Firmware programmingmode is inhibited by the FPU, the transceiver enters Usermode instead.If the transceiver receives the firmware data from a PC,“PG” appears on the display.

5. Check the connection between the TK-7150 and the per-sonal computer, and make sure that the TK-7150 is in theprogram mode.

6. Press write button in the window. A window opens onthe display to indicate progress of writing.

7. If writing ends successfully, the TX LED on the TK-7150lights.

8. If you want to continue programming other TK-7150, re-peat steps 3 to 6.

Note :This mode cannot entered if the firmware programming

mode is set to disable in the programming software (KPG-79D).

6-4. FunctionEach time you press the [PF4] key, the data transfer rate

alters (19200 / 38400 / 57600 bps).

Note :Normally, write in the high-speed mode (57600 bps).

7. Clone ModeProgramming data can be transferred from one radio to

another by connecting them via their modular microphonejacks. The operation is as follows (the transmit radio is themaster and the receive radio is a slave).

1. Turn the master TK-7150 power ON with the [PF6] keyheld down. The TK-7150 displays “CLONE”.If Firmware programming mode is inhibited by the FPU,the transceiver enters User mode instead.

2. Power on the slave TK-7150.3. Connect the cloning cable (No. E30-3382-05) to the modu-

lar microphone jacks on the master and slave.4. Press the [PF6] key on the master while the master dis-

plays “CLONE”. The data of the master is sent to theslave. While the slave is receiving the data, “PROGRAM”is displayed. When cloning of data is completed, the mas-ter displays “END”, and the slave automatically operatesin the User mode. The slave can then be operated by thesame program as the master.

5. The other slave can be continuously cloned. When the[PF6] key on the master is pressed while the master dis-plays “END”, the master displays “CLONE”. Carry outthe operation in steps 2 to 4.

6. To end cloning, first you must remove the cloning cable,then switch both master and slave TK-7150s off.

Note :Only the same models can be cloned together.

PROG 57600

[PF4]

PROG 19200

[PF4]

PROG 38400

[PF4]

8. Firmware Version InformationThis is a mode to confirm the internal firmware version.

1. Turn the transceiver ON while pressing the [PF3] key.The firmware version will appear on the LCD.When you release the [PF3] key, the transceiver automati-cally enters User mode.

Fig. 2

Fig. 3

Cloning cable(E30-3382-05)

REALIGNMENT

PROG 57600

[PF5]

SUM=[****]

[PF4]

Firmware checksum display

TK-7150

7

1. Installing Name PlatePunch out the name plate card. Then insert the plates

onto the relative function keys.You can reconfigure the name plates at any time.

3. External Speaker (KES-5)The external speaker output from the accessory connector

(6 pin) on the rear of the transceiver is 13W/4Ω. Use the KES-5.

3-1. Connection for the KES-5 with the TK-7150

When taking the AF output from the accessory

connector (6-pin) on the rear of the radioThe following tools are required for changing the connector.

• Extracting toolThe following extracting tool is recommended;Molex inc. Order No. : J5800-002 (W05-0878-00)

1. Remove the connector with jumper from the externalspeaker connector on the rear panel of the radio (Fig. 3-1).Note : Save the jumper, which is required when the radiois used without the external speaker.

2. Remove the terminals with the jumper from the connec-tor housing holes number 5 and 6 using the extractingtool.Removing the jumper lead (Fig. 3-2)

1) Insert the extracting tool (J5800-002) into the connec-tor while pushing the jumper lead in the direction of (a).

2) Push the extracting tool into collapse the barbs of thecrimp terminal.

3) Pull out the lead while continuing to push the extractingtool in the direction (b).

3. Cut off the end of the protection cover, insert the KES-5speaker cable into the protective cover.

4. Reinsert the terminal with the black and white stripe leadinto hole number 5, and the terminal with the black leadinto hole number 4 (Fig. 3-3).

5. Install the plug and protective cover on the accessory con-nector on the rear of the transceiver, then clamp the bot-tom of the protective cover with the supplied tie wrap.

INSTALLATION

Name plates forthe function keys

Punch out the name plate cards

Squeeze andinsert the plates

Name plates

Side view of the key

Fig. 1

2. Ignition Sense Cable (KCT-18)The KCT-18 is an optional cable to use the following func-

tions;

2-1. Ignition FunctionThe ignition function allows you to turn the transceiver’s

power on and off with the ignition key of your car. When youare driving with the ignition key on, the horn alert function isdisabled.

2-2. Timed Power Off FunctionThe timed power off function turns the transceiver’s

power off the time specified with the programming software(KPG-79D) after the ignition key is turned off. When you aredriving with the ignition key on, the horn alert function is dis-abled.

The ignition sense function and the timed power off func-tion can be used at the same time.

2-3. Modification1. Remove the short plug from the accessory connector (6

pins) on the rear of the transceiver.2. Cut off the end of the protective cover (accessory), insert

the KCT-18 into the protective cover, and insert it into pin1 (IGN) of the short plug.

3. Install the short plug and protective cover on the connec-tor on the rear of the transceiver, then clamp the bottomof the protective cover with the supplied tie wrap.

Fig. 2

Cut

Tie wrap

Protective cover

KCT-18

1

3 4

6

Short plug

Square-type plug(E37-1031-05)

(a)

(b)

Jumperlead

Extracting tool(J5800-002)

Crimp terminal

Crimp terminal(E23-0613-05)

Barbs

Cut

Tie wrap

Protective cover

4

5

Short plug

Black lead

Black/White lead

Speaker cable (to KES-5)

Fig. 3-1

Fig. 3-2

Fig. 3-3

TK-7150

8

4. Use as Public Address Speaker1. Remove the short plug from the 6-pin accessory connec-

tor on the rear of the radio. (Remove the jumpers as de-scribed in Section 3-1.)

2. Cut off the end of the protective cover, insert the speakercable into the protective cover, and insert it into pins 2 and3.

3. Install the plug and protective cover on the accessory con-nector on the rear of the transceiver, then clamp the bot-tom of the protective cover with the supplied tie wrap.

4. If you remove jumper shorting pins 5 and 6, the 20W PA(public address) voice signal is output from pins 2 and 3.(Only when the PA or SP switch is on.)

5. If you use the radio with pins 5 and 6 shorted, the internalspeaker is available.

Notes :• Relation ship between accessory connector (6-pins) con-

nection and speaker output.• When pins 5 and 6 are shorted; The internal speaker is

used.• When pins 5 and 6 are open and output is from pins 2 and

3; The 20W external speaker is used.

Cut

Tie wrap

Black lead

Black/White lead

Protective cover

2

3

Short plug

Speaker cable

Fig. 4

5. Single Control Head Remote Kit (KRK-9)

and Control Cable (KCT-22)1. Lift the tab on the bottom of the transceiver, then pull the

panel away from the transceiver.2. Remove the connector that binds the display unit to the

TX-RX unit.3. As shown in Figure 5-1, make sure that the rubber seal is

placed above the cable, then plug the 11-pin connectorinto the front panel PCB assembly.

4. Also, affix the ground wire to the front panel chassis, asshown in Figure 5-1, with the supplied screw.

5. Choose the remote wire position (right side or left side),then place the seal within the guide rail. Attach and se-cure the cover using the 2 binding screws.

6. Plug the 12-pin connector (from the rear panel) to theCN902 socket on the display PCB, as shown in Figure 5-2.

7. Push and secure the panel into the chassis so that the 6tabs on the top and bottom are securely fixed.

8. Plug the connector from the main panel into the CN703socket (Figure 5-3).

9. Push and secure the main panel so that the 6 tabs on thetop and bottom of the panel are securely fixed.

Rubber seal

KCT-22

Ground wire

Display unitCN902

Rear panel

Main panel

CN703

Fig. 5-1

Fig. 5-2

Fig. 5-3

INSTALLATION

TK-7150

9

6. Optional Board

6-1. Voice Scrambler Board Connection

Modification1. Remove the cabinet and shielding cover from the trans-

ceiver.2. Remove the panel.3. Delete R798 and R866 on the TX-RX unit.

ConnectionThe functions of pins of CN701 on the foil side of the TX-

RX unit are shown in the figure.Join the CN701 connector to the voice scrambler board via

the E37-0808-05 connector cable.Note : You must setup the FPU.

The Voice Scrambler Board is connected subsequentto the de-emphasis circuit.

TXI (MIC signal input)TXO (MIC signal output)RXI (Audio signal input)

AC (Scrambler control signal output)BC1 (Scrambler code signal output 1)BC2 (Scrambler code signal output 2)BC3 (Scrambler code signal output 3)BC4 (Scrambler code signal output 4)

NC (Non connection)NC (Non connection)

RXO (Audio signal output)PTOS (TX signal output)

8C (8V output)E (Ground)

CN7011

14

Voicescrambler

6-2. ANI Board Connection

Modification1. Remove the cabinet and shielding cover from the trans-

ceiver.2. Remove the panel.

ConnectionJoin the CN700 connector to the ANI board via the E37-

0808-05 connector cable.When the ANI board QE-2 is used, you must also use the

E37-1075-05 connector.Note : You must setup the FPU.

INSTALLATION

BUSY (Busy signal output)EMG (Emergency signal output)

KEY (TX control signal input)AUX (Emergency signal input)

INH (MIC mute signal input)STON (Side tone input)

TCNT (Speaker mute signal input)DATA (Data signal input)

E (Ground)8C (8V output)

PTOA (PTT signal output)DETO (Detected signal output)

NC (Non connection)NC (Non connection)

CN7001

14

ANI board

6-3. Example for Wire Connection

Picture (Scrambler board and ANI board)

Top view

Front view

R866

R798

TX-RX UNITComponent side

Fig. 6-1 Foil side of the TX-RX unit

Fig. 6-3 Component side of the TX-RX unit

Fig. 6-2

TK-7150

10

INSTALLATION

8. Horn Alert FunctionThe HR1 and HR2 pin of the accessory connector (25-pin)

on the rear of the transceiver is a relay and maximum currentis 1A.

8-1. Modification1. Remove the cabinet and shielding cover from the trans-

ceiver.2. Remove the panel.3. Remove the short plug from the 6-pin accessory connec-

tor on the rear of the transceiver.4. Delete R754 on the TX-RX unit.

Default Modification

R754 Enable Disable

State

7. Wiring of the Cable for Installing the

Built-in Type GPS Unit or Other PC Board1. Loosen the 2 screws ( 1 ) to remove the D-sub 25-pin

connector.2. Looses the 4 screws ( 2 ) to remove the Hardware fix-

ture.3. Remove the CN704 connector with the 6-pin lead wire.4. Take out the Hardware fixture.5. Cut the packing as shown in the illustratation.7. Tighten the 4 screws to attach the Hardware fixture.8. Tighten the 2 screws to fix attach D-sub 25-pin connector.

Fig. 7-1

Fig. 8

Fig. 7-2

Fig. 7-3

1 2

22

2

1

Packing

PackingHarewarefixture

Cut out

Cable of GPS unitor other board

Cable styling

HR1

HR2

HR1HR2

R754

TX-RX UNITComponent side

TK-7150

11

INSTALLATION

9. Special Instructions for Replacing the

Final Amplifier Q5To replace the Final Amp Q5, ensure to follow the instruc-

tions given below:

9-1. C89 and C90 Positions1. Ensure to solder C89 and C90 to securely contact Q5.

Note : The TX power may vary depending on the positionof C89 and C90.

9-2. Soldering1. Ensure to solder C89 and C90 with the earth spring legs as

illustrated in Fig. 9-3.Note : Use excessive solder to make it thicker than thethe electrodes of the chip.

2. Solder the terminals until the electrodes of the chip arefully covered. (Refer to Fig. 9-1.)Note : Use excessive solder to make it thicker than thethe electrodes of the chip. (Refer to Fig. 9-2.)

3. To solder the source side of C90 (FET Q5 source side),solder the earth springs until they are fully covered. (Referto Fig. 9-4.)

C89,C90

NG

C89,C90

OK

C89,C90

NG

C89,C90

OK

PCB

The C89 and C90 must contact securely the Q5 packageTop view

Side view

C89

C89

C90

C90

Q5

Metal plate Metal plate

Solder SolderSolder

ElectrodeConnect with solder

The C89 and C90 must contact securely the Q5 package

OKTop view

C89

C90

Q5

Fig. 9-1

Fig. 9-2

Fig. 9-3

Fig. 9-4

TK-7150

12

CIRCUIT DESCRIPTION

1. OutlineThe TK-7150 is a VHF/FM transceiver designed to operate

in the frequency range of 136 to 174MHz. Transmission out-put power is 50 watts. The maximum channel capacity is128.

The unit consists of receiver, transmitter, phase-lockedloop (PLL) frequency synthesizer, and control circuits.

2. Receiver CircuitThe receiver is double conversion superheterodyne, de-

signed to operate in the frequency range of 136MHz to174MHz.

The receiver circuit consists of the following : 2-1 front-end circuit, 2-2 first mixer, 2-3 IF amplifier circuit, 2-4 audioamplifier circuit, and 2-5 squelch circuit.

2-1. Front-end CircuitThe front-end circuit consists of former BPF (D209), RF

amplifier Q213, and latter BPF (D208 and D207). The BPFcovers frequency ranges 136 to 174MHz.

The latter BPF (D208 and D207) attenuates the unwantedsignals, and sends only the necessary signal to the firstmixer.

2-2. First MixerThe signal from the BPF is heterodyned with the first local

oscillator signal from the PLL frequency synthesizer circuit atthe first mixer DBM (Q209, Q210, Q211 and Q212) to be-come a 44.85MHz first intermediate frequency (IF) signal.The first IF signal is fed through two monolithic crystal filters(XF201; Wide, XF202; Narrow) to further remove spurioussignals.

2-3. IF AmplifierThe first IF signal is amplified by Q207 and Q206, and then

enters IC201 (FM system IC). The signal is heterodynedagain with a second local oscillator signal (44.395MHz) within IC201 to become a 455kHz second IF signal. The secondIF signal is fed through a 455kHz ceramic filters (CF201 andCF203; Wide, CF202 and CF204; Narrow) to further eliminateunwanted signal, and the quadrature detection circuit FM-de-tects the signal to produce a base-band signal and output itfrom pin 9.

SW

W/N

MCF (Narrow)XF202

MCF (Wide)XF201

IF AMPQ207D206D205

IF AMPQ206

44.850MHz

SW

W/N

SW

W/N

CF202,204(Narrow)

CF201,203(Wide)

D204D203

455kHz

DET

NOISE DETD202

SW

W/N

Q205

SW

W/N

SW SWAMP

44.85MHz

1st MIX DBMQ209~212

BPFD207,208

RF AMPQ213

BPFD209

NOISEAMPQ204

QUD

FM SYSTEM IC : IC201RSSI

DET

SQL

X20144.395MHz

Q509

Buff AMPQ513,515

RF AMPQ208

LPF

fRX+44.85MHz

RX VCO

AMPIC712 (A/2)

AINR AOUTRCODEC

IC713

CPU

IC701

IC714

DEOLPF

IC716 (A/2) IC724 IC722

MUTE

Q711 IC717AF

AMP

IC720

RXO RXI AFO

DAC

IC718

ASQ

RSSI

INT. SP

RX ANT

TX-RX UNIT (X57-657)

Fig. 1 Receiver circuit

TK-7150

13

2-4. Audio AmplifierThe recovered audio signal obtained from IC201 is ampli-

fied and anti-aliasing filtered by IC712 (A/2), inputted to theAINR terminal of CODEC IC (IC713), and audio processed byDSP (IC710). The processed audio signal from AOUTR termi-nal of IC713 is amplified and filtered by IC716 (A/2) to a suffi-cient level. The audio signal goes to an electronic volume(IC718) and then it passes through the amplifier (IC722), tothe input of multiplexer IC (IC717), and is amplified to drive aloudspeaker by an audio power amplifier (IC720). The audiooutput can be provided to external 4Ω speaker through the 6-pin ACC connector “ES1, ES2” on the rear panel. Q711 is amute switch.

2-5. Squelch CircuitThe output signal from IC201 enters FM IC again, then

passed through a band-pass filter.The noise component output from IC201 is amplified by

Q204 and rectified by D202 to produce a DC Voltage corre-sponding to the noise level. The DC voltage is sent to theanalog port of the CPU (IC701).

IC201 outputs a DC voltage (RSSI) corresponding to theinput of the IF amplifier.

3. Transmitter CircuitThe transmitter circuit consists of the following circuits : 3-

1 microphone circuit, 3-2 modulation level adjustment circuit,3-3 driver and final power amplifier circuit, and 3-4 automaticpower control circuit.

3-1. Microphone CircuitThe signal from the microphone passes through the mute

switch (Q901) and is then routed to the Display unit (X54-340)and TX-RX unit (X57-657). The signal then passes throughthe AGC circuit to avoid signal distortion.

This circuit consists of IC714, D711, D712, Q707, andQ708. The AGC is operated by controlling the + and – sidelevels of amplitude using the current obtained by positive andnegative detection of the amplified audio signal.

The audio signal is amplified by IC712 (B/2), input to theAINL terminal of CODEC IC (IC713), and audio processed byDSP (IC710). The processed audio signal from the AOUTLterminal of IC713 is amplified and filtered by IC716 (B/2), andamplified by the summing amplifier IC719 (B/2).

3-2. Modulation Level Adjustment CircuitThe output of the summing amplifier IC719 (B/2) is passed

to an electronic volume (IC718) for maximum deviation ad-justment before being applied to a varactor diode in the volt-age controlled oscillator VCO.

3-3. Driver and Final Power Amplifier CircuitThe transmit signal is generated by the TX VCO (Q507),

amplified by Q513 and Q 515. This amplified signal is ampli-fied by Q1, Q2, Q4, and Q5. And this signal is passed to theFINAL stage. The RF power amplifier consists of MOS FETtransistor.

AMP

DETSW

IC714(A/2)

ATT

Q707,708

SW

Q901

AMP

IC712(B/2)

LPF

IC716(B/2)

AMP

IC719(B/2)

DCAMP

IC715(B/2)

SW

IC717

IC718IC713

D711,712

IC717

VR700

D-SUBMI2

TXO TXIAINL

CODECIC AOUTL

D-SUBDI

DAC

MB

MOMIC

J901MIC jack

DISPLAY UNIT(X54-340) TX-RX UNIT (X57-657)

TX VCO

VCXO16.8MHz

Q507

Q1DriveAMP

Q513BuffAMP

Q515BuffAMP

Q2DriveAMP

Q4DriveAMP

Q5FinalAMP

X501

MO

MB REFAMP

DCAMP

Vcont

IC2(B/2)

IC2(A/2)

PC

SW

D3

DET DET

VR1Power adj.

D5 D6

ANT

Fig. 2 Microphone circuit

Fig. 3 Drive and final amplifier circuit

CIRCUIT DESCRIPTION

TK-7150

14

3-4. Automatic Power Control, Circuit and TransmitterThe automatic power control (APC) circuit stabilizes the

transmitter output power at a predetermined level, and con-sists of forward/reflected power detector circuits. The for-ward/reflected power detector circuits detects forward RFpower and reflected RF power to DC voltage, and consists ofa C coupling type detection circuit, RF detector D5/D6, andDC amplifier IC2 (A/2).

The voltage comparator (IC2 B/2) compares the voltageobtained by the above detected voltage with a reference volt-age, set using the microprocessor and IC718 and IC715.

An APC voltage proportional to the difference betweenthe sensed voltage and the reference voltage appears at theoutput of IC2. This output voltage controls the gate voltagefor the drive amplifier Q4 and final amplifier Q5, which keepsthe transmitter output power constant.

4. PLL Frequency SynthesizerThe transmit signal and the receive first L.O. signal are

generated by the PLL digital frequency synthesizer. The fre-quency synthesizer consists of a transmitter voltage con-trolled oscillator (TX VCO; Q507), a receiver voltage con-trolled oscillator (RX VCO; Q509), a buffer amplifier (Q513and Q515), an RF amplifier (Q516), a low-pass filter (Q501,Q503 and Q504), a PLL IC (IC501), and TX VCO/RX VCOswitches (Q510 and Q512).

In the transmit signal mode, an operating frequency pro-gramming data is sent to IC501, from the CPU (IC701), to setthe programmable counter within IC501. Q512 is turned onto activate the TX VCO and the output signal of the TX VCO isamplified by Q513 and Q516.

The signal is then divided down in frequency, at the pro-grammable counter in IC501, to 5.0kHz or 6.25kHz, 7.5kHzwhich is compared in phase with a 5.0kHz or 6.25kHz, 7.5kHzreference signal, derived from 16.8MHz VCXO (X501) and a

Q507

BUFFAMP

BUFFAMP

AMP

SWTX VCO

SW Q512

SWSW Q510Q514

8CL 8CL 8C 8T

8R

Q509

RX VCO

8CL

PLL IC

IC701CPU

8CL

STR

MO

5C

Q516

VCXO 5C

X50116.8MHz

Q513 Q515

LPF

LPF

12CL

Q501Q503Q504

D513D514

TXRX

IC501

SW SW

Q518 Q519

DT

CP

EP

UL

MB

Fig. 4 PLL circuit

1/3360 or a 1/2688, 1/2240 fixed counter in IC501, at thephase comparator in IC501. The VCXO operates at 16.8MHzand its frequency stability is maintained within 2.5ppm (tem-perature range of –30 to +60 degrees).

The phase comparator output signal is fed into a low-passfilter (Q501, Q503 and Q504) before being applied tot the TXvco as a frequency control voltage. This low-pass filter’spower is supplied by the DC/DC converter (Q502, Q505,Q506, Q508, and Q511). If an unlock condition occurs in thephase locked loop, this condition is detected by Q518 andQ519. This cause the transmitter 8V supply cut off, resultingin the prevention of an unauthorized transmission.

The transmitter modulation signals (processed Mic. audioand sub-audible signalling) are applied to the TX VCO for fre-quency modulation.

In the receive mode, the VCO is substituted with Q509(RX VCO) and it generates the receiver first local oscillatorsignal according to the data sent from the CPU (IC701). Thebasic operation of the synthesizer remains the same.

5. Control CircuitThe control circuit mainly consists of CPU, memory cir-

cuit, DSP circuit, and power supply circuit.

5-1. CPUThe CPU (IC701) controls the flash ROM (IC705), the DSP

(IC710), the receiver circuit, the transmitter circuit, the con-trol circuit, and the display circuit and transfers data to orfrom an external device.

5-2. Memory CircuitIC705 has a flash ROM with a capacity of 4M bits that

contains the control program for the CPU, the signal process-ing program for DSP and data such as channels and operatingfeatures.

This program can be easily written from an external de-vices. Data such as the operating status are programmedinto the EEPROM (IC704).

IC700/702

EEPROM

Reset IC

Shift register IC

IC718

D/A IC

IC703

232C driver

IC705IC704

IC103

Flash ROM

Interface IC

IC701CPU

IC706~709

DSP IC710

CODEC IC IC713

INVIC711

SW

X70012.288MHz

Q700

BEATSHIFT

Fig. 5 Control circuit

CIRCUIT DESCRIPTION

TK-7150

15

5-3. DSP CircuitThe DSP circuit filters transmit/receive audio signal and

encode/decode signalling (QT, DQT, MSK, DTMF, 2-Tone,LTR ID). This circuit consists of IC710, IC706, IC707, IC708,IC709 and IC713.

The receive audio signal is converted from analog to digitalby IC713 with a sampling frequency of 19.2kHz. The digitizedaudio signal is sent to DSP (IC710) to process the signallingsignal and audio signal. The processed digital audio signal isfed to CODEC (IC713), converted from digital to analog, andthe analog signal is output from pin 16 (AOUTR).

The transmit audio signal coming from IC714 (A/2) is am-plified by IC712 (B/2), fed to pin 3 (AINL) of CODEC (IC713),and converted from analog to digital at a sampling frequencyof 19.2kHz. The digitized transmit audio signal is AGC-pro-cessed, pre-emphasized and filtered at 300Hz to 3kHz byDSP (IC710), and the resulting signal is feed back to CODEC(IC713), and converted from digital to analog, and the analogsignal is output from pin 15 (AOUTL).

IC706, IC707, IC708 and IC709 are interface IC betweenthe CPU operated at 5.0V and the DSP operated at 3.3V.

5-4. Power Supply CircuitThe voltage is always applied from +B. D103 protects

IC102 (DFF) against overvoltage.Pulses from power switch are input to the IC102 clock line

and the CPU (IC701). These clock pulses reverse the outputHigh (radio : turn off) → Low (radio : turn on), do not reversethe output Low → High. The CPU (IC701) output the pulse toIC102 set line to reverse the output Low → High.

IGN is input to the IC102 reset line and the CPU (IC701).When the IC102 reset voltage rise, the output goes Low (ra-

D103AVR

D106SW

D102SW

Q102SW

Q101SW

D104SW

IC102DFF

Q111SW

Q112,113SW

IC701CPU

D105SW

Q109,110SW

D109AVR

Q710SW

Q108SW

Q713SW

R112

IGN PSW

+B

Q103SW SB

Fig. 6 Power supply circuit

dio : turn on). When IGN falls, the CPU (IC701) output thepulse to IC102 set line to reverse the output Low → Highafter the programmed time expire (Timed power off func-tion).

If 24V is supplied to the radio by mistake, Q102 turns on,Q101 turns off, the power is forced to be turned off.

This circuit consists of IC104 (8V), IC105 (5V), IC106(3.3V), IC108 (3.3V) and IC107 (1.8V).

6. Display CircuitThe display unit consists of CPU (IC904), LCD assembly,

LED, and other components.Channels are changed by the rotary switch (S1). The up/

down signals from the rotary switch enter the CPU (IC904),and converted to a serial data signal, and are sent to the CPU(IC701) in the TX-RX unit. The on/off signals of keys otherthan the power switch, and the PTT and HOOK signals, areconverted to serial data and sent to the CPU (IC701) in theTX-RX unit.

Data is displayed on the 12 digits and 3 digits dot matrixalphanumeric display.

7. RS-232C CircuitThe RS-232C circuit connects the RS-232C serial port of a

personal computer directly to this model to perform FPU op-eration (Read and Write). The FPU operation can also be per-formed by connecting a programming cable (KPG-46) to thelocal microphone on the front panel. The 232C driver IC(IC703) changes the TTL-232C level. The firmware can onlybe rewritten with the local microphone on the front panel.

PF1

D91

0

PF2 PF3 PF4 PF5 PF6

POWERSW

RST

PSW

SBAVR

IC901

5V

RST

X90112MHz

SW

SW

AF VR

D90

9D

908

SW

SW

D91

1D

913

D91

4

SWQ904 Q908

Key back lamp

Q903REFD907

SB

IC904CPU

LCD

PTTHK

Q907D915RX LED

SW

Q906D912TX LED

Q902

BEAT SHIFT

IRSES2

DM

1 8

MIC

PT

TS

BH

KM

E E 8LC

MIC

INT SPRotary SW

J901

Fig. 7 Display circuit

CIRCUIT DESCRIPTION

TK-7150

16

1-1. Pin Function

Pin No. Name I/O Function

1 I/O Go to port check mode

L : Port check mode, H : User mode

2 WN O Wide/Narrow H : Narrow, L : Wide

3 8RC O 8R Control H : 8R on, L : 8R off

4 INTx O INT Request to DSP L : INT request

5 STR O VCO TX/RX H : TX VCO, L : RX VCO

6 BYTE +5V

7 CNVss GND

8 8TC O 8T Control H : 8T on, L : 8T off

9 SFT O Beat Shift H : SFT on, L : SFT off

10 RESET CPU Reset

11 Xout 12.288MHz

12 Vss GND

13 Xin 12.288MHz

14 Vcc +5V

15 NMI I Not Used

16 IGN I Ignition Sense

H : IGN. Sense off, L : IGN. Sense on

17 PSI I Power Down Det L : Power down det

18 LD O D/A Converter LD

19 CP O PLL IC Clock

20 EP O PLL IC Enable

21 CONTROL O Connect Codec TX Out to speaker line

H : Connect, L : Disconnect

22 DT O Common Data

23 CK O Common Clock

24 SOE O Shift Register 1 OE

25 STB1 O Shift Register 1 Strobe

26 AI4 I AUX Input No.4 H : Inactive, L : Active

27 RXD2 I Head Comm (RXD)

28 TXD2 O Head Comm (TXD)

29 TXD1 O Acc com2 (TXD)

30 RXD1 I Acc com2 (RXD)



33 TXD0 O Acc com1 (TXD)

34 RXD0 I Acc com1 (RXD)


36 O Not Used

37 RDY I Hardware BUS Wait Control

38 ALE O Cannot Use (Address Latch)


39 HOLD I Cannot Use (BUS Hold)

40 HLDA O Cannot Use (BUS Hold Status)

41 BCLK O Cannot Use (Sys Clock Output)

42 RD O Flash ROM : RD, DSP : HDS1

43 BHE O Cannot Use (BUS High Enable)

44 WR O Flash ROM : WR, DSP : HDS2

45 SBC O SB Control H : SBC off, L : SBC on

46 AM O Audio Mute H : SP mute, L : SP unmute

47 HCS O DSP HCS

48 CS0 O Flash CS

49~59 A19~A9 O Cannot Use (Flash ROM Address BUS)

60 Vcc +5V

61 A8 O Cannot Use (Flash ROM Address BUS)

62 Vss GND

63~70 A7~A0 O Cannot Use (Flash ROM Address BUS)

71 PTO O Scrambler TX/RX Control H : RX, L : TX

72 PSW I Pow. Switch Det H : Inactive, L : Active

73 Inty I INT Request from DSP L : INT request

74 RS O DSP Reset H : DSP reset

75 SCL O EEPROM Clock

76 SDA I/O EEPROM Data

77 KEY I TX Request from ANI board L : TX request

78 STB2 O Shift Register 2 Strobe

79~86 D7~D0 Cannot Use (Flash ROM Data BUS)

87 PDET I Power Det Level

88 CDET I Power Current Det Level

89 TEMP1 I Power Temp1 Level

90 TEMP2 I Power Temp2 Level

91 ASQ I Analog Squelch Level

92 RSSI I RSSI Level

93 UL I Unlock Level

94 Avss GND

95 I Not Used

96 Vref +5V

97 Avcc +5V

98 AUX I Emergency Channel Request from ANI

board L : Channel request

99 INH I Audio Inhibit from ANI board

H : SP unmute, L : SP mute

100 TCNT I Tone Control from ANI board

L : Board tone output request

SEMICONDUCTOR DATA

1. CPU : 30620M8A-5H1GP (TX-RX Unit IC701)

TK-7150

17

2. Shift Register 1 : BU4094BCFV (TX-RX Unit IC702)

2-1. Pin Function

Pin No. Port Name Name I/O Function

1 STROBE STB1 I From CPU STB1 (Pin No.25)

2 SERIAL IN DATA I From CPU Common Data (Pin No.22)

3 CLOCK CLK I From CPU Common Clock (Pin No.23)

4 Q1 MI2 O External Mic Mute

L : Mute, H : Unmute

5 Q2 DI O External Data Line Mute

L : Mute, H : Unmute

6 Q3 SP O Front SP/EXT SP Change

L : Front SP, H : External SP

7 Q4 HR O Horn Alert L : Relay off, H : Relay on

8 VSS VSS GND

9 Qs Qs O No Connect

10 Qs’ Qs’ O No Connect

11 Q8 AO4 O AUX Output No.4

H : AUX Out No.4 on, L : AUX Out No.4 off







15 OUTPUT SOE I From CPU SOE (Pin No.24)

ENABLE L → Inactive, H → Active

16 VDD VDD +5V

3. Shift Register 2 : BU4094BCFV (TX-RX Unit IC700)

3-1. Pin Function


1 STROBE STB2 I From CPU STB1 (Pin No.21)

2 SERIAL IN DATA I From CPU Common Data (Pin No.22)

3 CLOCK CLK I From CPU Common Clock (Pin No.23)

4 Q1 BC1 O Scrambler Code 1 (For SCR)

L : SCR Code1 off, H : SCR Code1 on







8 VSS VSS GND


9 Qs Qs O No Connect

10 Qs’ Qs’ O No Connect

11 Q8 AC O Scrambler ON/OFF (For SCR)

L : Scrambler on, H : Scrambler off

12 Q7 BUSY O Channel Busy (For ANI)

L : Busy, H : Not Busy

13 Q6 EMG O Emergency ON/OFF (For ANI)

L : Emergency on, H : Emergency off

14 Q5 PTO O PTT Output (For ANI)

L : PTT on, H : PTT off

15 OUTPUT SOE GND

ENABLE

16 VDD VDD +5V

4. D/A Converter : M62364FP (TX-RX Unit IC718)

4-1. Pin Function


1 Vin1 I AF Volume First IN

2 Vout1 O AF Volume First OUT

3 Vout2 O AF Volume Second OUT

4 Vin2 I AF Volume Second IN (From DAC Pin No.2)

5 VDD +5V

6 LD O From CPU LD(Pin No.18)

7 CK O From CPU Common Clock (Pin No.23)

8 DT O From CPU Common Data (Pin No.22)

9 Vin3 I GND

10 Vout3 O Tune Varicap

11 Vout4 O Side Tone Out

12 Vin4 I Side Tone (From Option Board)

13 Vin5 I

14 Vout5 O Max Deviation

15 Vout6 O

16 Vin6 I DQT Balance

17 Do O Open

18 VDAref I

19 Reset I +5V

20 GND GND

21 Vin7 I +5V

22 Vout7 O Frequency Adjust

23 Vout8 O Auto Power Control

24 Vin8 I +5V

SEMICONDUCTOR DATA

TK-7150

18

SEMICONDUCTOR DATA

5-1. Pin Function


1 DISP O LCD Display ON/OFF L : On, H : Off

2~5 O Not used

6 BYTE GND

7 CNVss GND

8 O Not used

9 SFT O Beat Shift L : Shift off, H : Shift on

10 RESET CPU Reset

11 Xout 12.0MHz

12 Vss GND

13 Xin 12.0MHz

14 Vcc +5V

15 NMI I Not used

16~19 O Not used

20 MIC O Mic Mute L : Mute, H : Unmute

21,22 O Not used

23 DM I/O Mic Keypad Data

24 O Not used

25 BLC O Mic Keypad Backlight Control L : Off, H : On

26 O Not used

27 RXD2 I Body Comm (RXD)

28 TXD2 O Body Comm (TXD)

29 TXD1 O PC Comm (TXD)/connect to PTT

30 RXD1 I Open (RXD)

31 I Not used

32 O Not used

33 TXD0 O Open (TXD)

34 RXD0 I PC Comm (RXD)/connect to HOOK

35 HOOK I HOOK/connect to RXD0

36 PTT I PTT/connect to TXD1

37 O Not used

38 BCK1 O PF Key Backlight Control L : Off, H : On

39 PF1 I PF1 Key Input







45~49 O Not used

50 BCK2 PF Key Backlight Control L : Off, H : On

51 TP3 I Head Check Mode L : Head check mode,

H : Not go to head check mode

52~56 O Not used

57 BUSY O BUSY LED L : Off, H : On

58 TX O TX LED L : Off, H : On

59 O Not used

60 Vcc +5V

61 O Not used

62 Vss GND

63~66 O Not used

67 RSW4 I Rotary SW4




71~81 O Not used

82 LEDK O LCD Back Light Control L : Off, H : On

83 DO O LCD Data Output

84 DI I LCD Data Input

85 CL O LCD Clock

86 CE O LCD CS

87~92 O Not used

93 VOL I Audio Volume Input

94 AVss GND

95 O Not used

96 AVref +5V

97 AVcc +5V

98~100 O Not used

5. Display CPU : 30622M4A-443GP (Display Unit IC904)

TK-7150

19

6. DSP : 320VC5402PGE (TX-RX Unit IC710)

6-1. Pin Function


1,2,12,15, NC1~NC18 - Not used (No connect)

35~38,

71~74,80,

90,110,126,

143,144

6,58,69,81, HD0~HD7 I/O HPI data bus

95,120,124,

135

5,7~11,105, A0~A19 O Not used (No connect)

107~109,

131~134,

136~141,

13 HAS I HPI address strobe (Pull up)

17 HCS I HPI chip select

18 HR/W I HPI read/write

19 READY I Data ready (Pull up)

20 PS O Not used (No connect)

21 DS O Not used (No connect)

22 IS O Not used (No connect)

23 R/W O Not used (No connect)

24 MSTRB O Not used (No connect)

25 IOSTRB O Not used (No connect)

26 MSC O Not used (No connect)

27 XF O CODEC control

(H : power down, L : active)

28 HOLDA - Not used (No connect)

29 IAQ - Not used (No connect)

30 HOLD I Hold (Pull up)

31 BIO I Serial data synchronize input

32 MP/MC I Not used (Pull down)

39 HCNTL0 I HPI control 0

41 BCLKR0 I Receive clock output (SCLK : 614.4kHz)

42 BCLKR1 - Master clock output (MCLK : 4.9152MHz)

43 BFSR0 I Frame sync. for receiver output

(LRCK : 19.2kHz)

44 BFSR1 I Not used (No connect)

45 BDR0 I Serial data receive input

46 HCNTL1 I HPI control 1

47 BDR1 - Not used (No connect)

48 BCLKX0 I Transmit clock input (SCLK : 614.4kHz)

49 BCLKX1 O Not used (No connect)

51 HINT/TOUT1 O Interrupt for Host CPU/Boot mode

select (Pull up)


53 BFSX0 I Frame sync.for transmitter input

(LRCK : 19.2kHz)

54 BFSX1 I Not used (No connect)

55 HRDY - Not used (No connect)

59 BDX0 O Serial data transmit output

60 BDX1 - Not used (No connect)

61 IACK - Not used (No connect)

62 HBIL I Byte identification (HPI)

63 NMI I Not used (Pull up)

64 INT0 I Command interrupt from Host CPU

65 INT1 I Not used (Pull up)

66 INT2 I Boot mode select (Pull up)

67 INT3 I Not used (Pull up)

77 CLKMD1 I Clock mode select (Pull down)

78 CLKMD2 I Clock mode select (Pull up)

79 CLKMD3 I Clock mode select (Pull down)

82 TOUT0 - Not used (No connect)

83 EMU0 I/O Emulator 0 (to JTAG connector)

84 EMU1/OFF I/O Emulator 1 (to JTAG connector)

85 TDO O Test data output (to JTAG connector)

86 TDI I Test data input (to JTAG connector)

87 TRST I Test reset (to JTAG connector)

88 TCK I Test clock (to JTAG connector)

89 TMS I Test mode select (to JTAG connector)

92 HPIENA I Not used (Pull up)

94 CLKOUT O Not used (No connect)

96 X1 - 12.288MHz (System clock)

97 X2/CLKIN - 12.288MHz (System clock)

98 RS I DSP reset input

99~104, D0~D15 - Not used (No connect)

113~119,

121~123

127 HDS1 I HPI data strobe1 (Pull up)

129 HDS2 I HPI data strobe2 (Pull down)

3,14,34,40, Vss - GND

50,57,70,

76,93,106,

111,128

4,33,56, DVDD - VDD for I/O pins (+3.3V)

75,112,130

16,52,68, CVDD - VDD for core CPU (+1.8V)

91,125,142

SEMICONDUCTOR DATA

TK-7150

20

1. Display Unit (X54-3400-10)

Ref. No. Part Name Description

IC901 IC Voltage regulator

IC902 IC Voltage detector

IC904 IC CPU

Q901 FET MIC switch

Q902 FET DC switch

Q903 Transistor Current driver

Q904~908 Transistor DC switch

Q909,910 Transistor Inverter

Q911 Transistor DC switch

D902~906 Diode Surge protector

D907 Zener diode Voltage reference

D908~911 LED Key backlight

D912 LED TX light

D913,914 LED Key backlight

D915 LED RX light

D916 Zener diode Surge protector

D917 Varistor Current protector


2. TX-RX Unit (X57-6570-10)


IC1 IC Not used

IC2 IC DC amplifier


IC102 IC D flip-flop


IC104~108 IC Voltage regulator

IC201 IC FM IF system

IC202 IC Multiplexer

IC501 IC PLL

IC700 IC Shift register

IC701 IC CPU

IC702 IC Shift register

IC703 IC RS232C transceiver

IC704 IC EEPROM

IC705 IC Flash ROM

IC706 IC Bus transceiver

IC707~709 IC OR gate

IC710 IC DSP


IC711 IC Inverter

IC712 IC AF amplifier

IC713 IC CODEC

IC714 IC MIC amplifier/AGC

IC715 IC Buffer amplifier

IC716 IC Anti-aliasing filter


IC718 IC D/A converter


IC720 IC Audio power amplifier

IC721 IC DC amplifier


IC723 IC Voltage regulator



Q1,2 Transistor RF amplifier

Q4 FET Drive amplifier

Q5 FET Final amplifier


Q102 Transistor Switch

Q103 FET DC switch


Q201~203 Transistor W/N switch

Q204 Transistor Noise amplifier

Q205 Transistor W/N switch

Q206 Transistor IF amplifier

Q207 Transistor Pre IF amplifier

Q208 Transistor RF amplifier

Q209~212 FET Mixer

Q213 Transistor RF amplifier

Q501 Transistor Active filter

Q502 FET Oscillator

Q503,504 Transistor Active filter

Q505,506 Transistor DC switch

Q507 FET TX oscillator

Q508 Transistor AVR

Q509 FET RX oscillator

Q510 Transistor TX/RX switch

Q511 Transistor Ripple filter

Q512 Transistor TX/RX switch

COMPONENTS DESCRIPTION

TK-7150

21


Q513 Transistor Buffer amplifier

Q514 Transistor Inverter

Q515 Transistor Buffer amplifier

Q516 Transistor Amplifier

Q517 Transistor Ripple filter



Q700 FET DC switch


Q707,708 Transistor MIC gain switch



Q712,713 FET DC switch





D2 Zener diode Voltage protection

D3,4 Diode ANT switch

D5,6 Diode RF detector

D7 Diode Temperature compensation

D11 Diode Surge protector

D101 Diode Protection of reverse connection

D102,103 Zener diode Voltage reference


D104~106 Diode DC switch

D108 Diode Surge protector


D201 Diode DC switch

D202 Diode Noise detection

D203~206 Diode Wide/Narrow switch

D207~209 Varicap BPF tuning

D501~508 Varicap Frequency control

D509,510 Diode Voltage doubler

D511 Varicap Modulator


D513,514 Diode RF switch



D704 Diode Voltage reduction



D711,712 Diode AF detector



D785~790 Zener diode Surge protector



D794 Diode Delay

COMPONENTS DESCRIPTION

TK-7150

22

PARTS LIST

Chip capacitor

Code L W TEmpty 5.6±0.5 5.0±0.5 Less than 2.0

A 4.5±0.5 3.2±0.4 Less than 2.0B 4.5±0.5 2.0±0.3 Less than 2.0C 4.5±0.5 1.25±0.2 Less than 1.25D 3.2±0.4 2.5±0.3 Less than 1.5E 3.2±0.2 1.6±0.2 Less than 1.25F 2.0±0.3 1.25±0.2 Less than 1.25G 1.6±0.2 0.8±0.2 Less than 1.0H 1.0±0.05 0.5±0.05 0.5±0.05

Chip resistor

Code L W TE 3.2±0.2 1.6±0.2 1.0F 2.0±0.3 1.25±0.2 1.0G 1.6±0.2 0.8±0.2 0.5±0.1H 1.0±0.05 0.5±0.05 0.35±0.05

• Rating wattage

Code Wattage Code Wattage Code Wattage1J 1/16W 2C 1/6W 3A 1W2A 1/10W 2E 1/4W 3D 2W2B 1/8W 2H 1/2W

(Less than 10pF)

Code B C D F G(pF) ±0.1 ±0.25 ±0.5 ±1 ±2

CAPACITORS

C C 4 5 T H 1 H 2 2 0 J1 2 3 4 5 6

1 = Type ... ceramic, electrolytic, etc. 4 = Voltage rating2 = Shape ... round, square, etc. 5 = Value3 = Temp. coefficient 6 = Tolerance

• Temperature coefficient

1st Word C L P R S T UColor* Black Red Orange Yellow Green Blue Violetppm/°C 0 –80 –150 –220 –330 –470 –750

• Tolerance (More than 10pF)

Code C D G J K M X Z P No code(%) ±0.25 ±0.5 ±2 ±5 ±10 ±20 +40 +80 +100 More than 10µF : –10~+50

–20 –20 –0 Less than 4.7µF : –10~+75

• Voltage rating

2nd word A B C D E F G H J K V 1st word

0 1.0 1.25 1.6 2.0 2.5 3.15 4.0 5.0 6.3 8.0 –1 10 12.5 16 20 25 31.5 40 50 63 80 352 100 125 160 200 250 315 400 500 630 800 –3 1000 1250 1600 2000 2500 2150 4000 5000 6300 8000 –

CHIP CAPACITORS

(EX) C C 7 3 F S L 1 H 0 0 0 J Refer to the table above.1 2 3 4 5 6 7 1 = Type

(Chip) (CH, RH, UJ, SL) 2 = Shape3 = Dimension

(EX) C K 7 3 F F 1 H 0 0 0 Z 4 = Temp. coefficient1 2 3 4 5 6 7 5 = Voltage rating

(Chip) (B, F) 6 = Value7 = Tolerance

RESISTORS

• Chip resistor (Carbon)

(EX) R D 7 3 E B 2 B 0 0 0 J1 2 3 4 5 6 7

(Chip) (B, F)

• Carbon resistor (Normal type)

(EX) R D 1 4 B B 2 C 0 0 0 J1 2 3 4 5 6 7

(Chip) (B, F)

1 = Type ... ceramic, electrolytic, etc. 5 = Voltage rating2 = Shape ... round, square, etc. 6 = Value3 = Dimension 7 = Tolerance4 = Temp. coefficient

CC45Color*

2nd Word G H J K Lppm/°C ±30 ±60 ±120 ±250 ±500

Example : CC45TH = –470±60ppm/°C

• Capacitor value

010 = 1pF 2 2 0 = 22pF100 = 10pF101 = 100pF Multiplier102 = 1000pF = 0.001µF 2nd number103 = 0.01µF 1st number

L

W

T

• Dimension

TK-7150

23

PARTS LIST New Parts. indicates safety critical components.Parts without Parts No. are not supplied.Les articles non mentionnes dans le Parts No. ne sont pas fournis.Teile ohne Parts No. werden nicht geliefert.

L : Scandinavia K : USA P : CanadaY : PX (Far East, Hawaii) T : England E : EuropeY : AAFES (Europe) X : Australia M : Other Areas

1 1B A01-2185-12 CABINET2 3A A62-1037-03 PANEL ASSY

4 1C B11-1297-04 NAME PLATE5 1D B62-1619-00 INSTRUCTION MANUAL6 3A B72-2075-04 MODEL NAME PLATE

8 2A E04-0167-05 RF COAXIAL PECEPTACLE (M)9 1C E30-3478-05 DC CORD ASSY- E37-0808-05 LEAD WIRE WITH CONNECTOR11 3A E37-1002-15 LEAD WIRE WITH CONNECTOR12 1A E37-1003-05 LEAD WIRE WITH CONNECTOR (6P/ACC)

13 3A E37-1004-05 LEAD WIRE WITH CONNECTOR (TXRX-CONT)14 1B,2C E37-1031-05 LEAD WIRE WITH CONNECTOR (SHORT PLUG)15 1A E37-1074-05 LEAD WIRE WITH CONNECTOR (DC)- E37-1075-05 LEAD WIRE WITH CONNECTOR

18 2C F05-1537-05 FUSE (BLADE) (15A/32V)19 2B F09-0445-05 CAP (D-SUB)20 2C F29-0478-05 PROTECTIVE COVER

22 2B G02-0861-04 FLAT SPRING23 2B G02-0894-04 EARTH SPRING24 2B G02-0896-04 FLAT SPRING25 2B G02-0900-04 EARTH SPRING26 2B G02-1801-03 EARTH SPRING

27 2B G02-1802-04 EARTH SPRING28 1B G53-1551-02 PACKING29 2A G53-1552-03 PACKING30 1A G53-1554-03 PACKING31 3A G53-1555-04 PACKING

33 3D H52-1894-02 ITEM CARTON CASE

35 2C J19-1584-05 HOLDER36 2B J21-8437-14 HARDWARE FIXTURE37 1C J29-0697-03 BRACKET38 2C J61-0307-05 BAND

40 3A K29-9221-03 KNOB41 3A K29-9222-02 KEY TOP

A 1B N09-2409-05 HEXAGON HEAD SCREWB 3A N10-2070-46 HEXAGON NUTC 1A,2B,3B N67-3008-46 PAN HEAD SEMS SCREW WD 3A N80-2606-46 PAN HEAD TAPTITE SCREWE 2B,3B N87-2606-46 BRAZIER HEAD TAPTITE SCREW

F 1B N87-2620-46 BRAZIER HEAD TAPTITE SCREWG 1B,2B N87-3008-45 BRAZIER HEAD TAPTITE SCREW43 2C N99-2033-05 SCREW SET

45 3A T07-0738-05 SPEAKER46 1C T91-0621-15 MICROPHONE

48 3A X54-3400-10 DISPLAY UNIT

101 3A B38-0875-05 LCD ASSYD908-911 B30-2254-05 LEDD912 B30-2193-05 LED (RED)D913,914 B30-2254-05 LEDD915 B30-2194-05 LED (GREEN)

C901 CC73GCH1H101J CHIP C 100PF JC902 CK73GB1H102K CHIP C 1000PF KC903 CK73GB1H103K CHIP C 0.010UF KC904 CK73GB1H102K CHIP C 1000PF KC905,906 CC73GCH1H101J CHIP C 100PF J

C907 CK73GB1H102K CHIP C 1000PF KC909,910 CC73GCH1H101J CHIP C 100PF JC911,912 C92-0628-05 CHIP-TAN 10UF 10WVC914 CK73GB1H102K CHIP C 1000PF KC915-917 CC73GCH1H101J CHIP C 100PF J

C918,919 CK73GB1H103K CHIP C 0.010UF KC921 CK73GB1H103K CHIP C 0.010UF KC922 CC73GCH1H060B CHIP C 6.0PF BC923 CK73GB1C223K CHIP C 0.022UF KC924 C92-0628-05 CHIP-TAN 10UF 10WV

C925 CK73GB1H102K CHIP C 1000PF KC926,927 CC73GCH1H270J CHIP C 27PF JC928 CK73GB1H103K CHIP C 0.010UF KC929,930 CK73GB1H102K CHIP C 1000PF KC931 CK73GB1H103K CHIP C 0.010UF K

C932 CK73GB1H102K CHIP C 1000PF KC933 CK73GB1H103K CHIP C 0.010UF KC934,935 CK73GB1H102K CHIP C 1000PF KC938,939 CK73GB1H102K CHIP C 1000PF KC941,942 CK73GB1H102K CHIP C 1000PF K

C943 CK73GB1H103K CHIP C 0.010UF KC944 CK73GB1H102K CHIP C 1000PF K

CN901 E40-5538-05 PIN ASSYCN902 E40-6140-05 PIN ASSYCN905 E40-5823-05 FLAT CABLE CONNECTORCN906 E40-5752-05 PIN ASSYJ901 E08-0877-05 MODULAR JACK

W1 3A E37-1057-05 LEAD WIRE WITH CONNECTOR

L901,902 L40-1095-34 SMALL FIXED INDUCTOR (1UH)X901 L77-1863-05 CRYSTAL RESONATOR (12.0MHZ)

R902 RK73GB1J104J CHIP R 100K J 1/16WR904,905 R92-1252-05 CHIP R 0 OHM J 1/16WR906,907 RK73GB1J102J CHIP R 1.0K J 1/16WR908 RK73GB1J473J CHIP R 47K J 1/16WR909 RK73GB1J472J CHIP R 4.7K J 1/16W

R910 RK73GB1J104J CHIP R 100K J 1/16WR913 RK73GB1J473J CHIP R 47K J 1/16WR914 RK73GB1J561J CHIP R 560 J 1/16WR915 R92-0670-05 CHIP R 0 OHMR916-918 RK73GB1J473J CHIP R 47K J 1/16W

R919 RK73GB1J333J CHIP R 33K J 1/16WR920 RK73FB2A560J CHIP R 56 J 1/10W

Ref. No. Address Parts No. Description Desti-nation

Newparts Ref. No. Address Parts No. Description Desti-

nationNewparts

TK-7150 DISPLAY UNIT (X54-3400-10)

TK-7150 (Y51-4910-10)

DISPLAY UNIT (X54-3400-10)

TK-7150

24

PARTS LIST

R922 RK73GB1J333J CHIP R 33K J 1/16WR923-925 RK73GB1J102J CHIP R 1.0K J 1/16WR926,927 RK73FB2A151J CHIP R 150 J 1/10WR928 RK73GB1J102J CHIP R 1.0K J 1/16WR931 RK73FB2A272J CHIP R 2.7K J 1/10W

R932,933 RK73GB1J102J CHIP R 1.0K J 1/16WR934 RK73FB2A272J CHIP R 2.7K J 1/10WR935-941 RK73GB1J473J CHIP R 47K J 1/16WR942 RK73GB1J472J CHIP R 4.7K J 1/16WR943 RK73GB1J333J CHIP R 33K J 1/16W

R944 RK73GB1J471J CHIP R 470 J 1/16WR945 RK73GB1J6R8J CHIP R 6.8 J 1/16WR946,947 R92-2021-05 CHIP R 2.2 J 1/2WR948 RK73GB1J104J CHIP R 100K J 1/16WR949 RK73GB1J102J CHIP R 1.0K J 1/16W

R950 RK73GB1J224J CHIP R 220K J 1/16WR951 RK73GB1J102J CHIP R 1.0K J 1/16WR952-955 RK73GB1J104J CHIP R 100K J 1/16WR956-959 RK73GB1J102J CHIP R 1.0K J 1/16WR960 RK73GB1J472J CHIP R 4.7K J 1/16W

VR901 R31-0630-05 VARIABLE RESISTOR

S1 3A S60-0423-05 ROTARY SWITCH

D902-906 DA204U DIODED907 02CZ9.1(X,Y) ZENER DIODED916 02DZ18(X,Y) ZENER DIODED917 MINISMDC020 VARISTORD918 02DZ18(X,Y) ZENER DIODE

IC901 TA7805F MOS ICIC902 RH5VL42C MOS ICIC904 30622M4A-443GP MPUQ901 2SJ243 FETQ902 2SK1824 FET

Q903 2SD1760 TRANSISTORQ904-908 DTC114EE DIGITAL TRANSISTORQ909-911 DTC144EE DIGITAL TRANSISTOR

C1-3 CK73GB1H102K CHIP C 1000PF KC4 CC73GCH1H100D CHIP C 10PF DC5-9 CK73GB1H102K CHIP C 1000PF KC10 CC73GCH1H390J CHIP C 39PF JC11-14 CK73GB1H102K CHIP C 1000PF K

C15 CC73GCH1H270J CHIP C 27PF JC16 CK73GB1H102K CHIP C 1000PF KC17 CC73GCH1H220J CHIP C 22PF JC18,19 CK73GB1H102K CHIP C 1000PF KC20 CC73GCH1H330J CHIP C 33PF J

C21 CC73GCH1H820J CHIP C 82PF JC22 CK73FB1H102K CHIP C 1000PF KC23,24 C93-0602-05 CHIP C 820PF KC25 CC73FCH1H470J CHIP C 47PF JC26 CK73GB1H102K CHIP C 1000PF K

C27 CC73FCH1H121J CHIP C 120PF JC29 CK73FB1H102K CHIP C 1000PF KC30 CK73GB1H102K CHIP C 1000PF KC31 C93-0603-05 CHIP C 1000PF KC32,33 CK73GB1H102K CHIP C 1000PF K

C34 CM73F2H241J CHIP C 240PF JC35 C93-0779-05 CERAMIC CAP 36PF 500WVC36 C93-0565-05 CHIP C 27PF JC37,38 C93-0602-05 CHIP C 820PF KC39 C93-0567-05 CHIP C 39PF J

C40 C93-0602-05 CHIP C 820PF KC42,43 CC73GCH1H0R5C CHIP C 0.5PF CC44 CM73F2H390J CHIP C 39PF JC45 CK73GB1H102K CHIP C 1000PF KC46 C93-0566-05 CHIP C 33PF J

C47,48 CC73GCH1H0R5C CHIP C 0.5PF CC49 CK73GB1H102K CHIP C 1000PF KC50 C93-0565-05 CHIP C 27PF JC51 CK73GB1H102K CHIP C 1000PF KC53 CK73GB1H102K CHIP C 1000PF K

C54 CC73GCH1H040C CHIP C 4.0PF CC62 CC73FCH1H100D CHIP C 10PF DC63 CK73FB1E224K CHIP C 0.22UF KC65 CK73GB1H102K CHIP C 1000PF KC67 CK73GB1E473J CHIP C 0.047UF J

C74 C93-0564-05 CHIP C 22PF JC75 CC73GCH1H150J CHIP C 15PF JC77 CM73F2H220J CHIP C 22PF JC80 CK73GB1H102K CHIP C 1000PF KC89 CM73F2H300J CHIP C 30PF J

C90 CM73F2H300J CHIP C 30PF JC92 C90-4085-05 ELECTRO CAP 47UF 20WVC93,94 C90-5299-05 ELECTRO CAP 470UF 25WVC101 C92-0777-05 ELECTRO CAP 1000UF 25WVC102 CK73GB1E473J CHIP C 0.047UF J

C103 CC73GCH1H471J CHIP C 470PF JC104 CC73GCH1H101J CHIP C 100PF JC105,106 CK73GB1E473J CHIP C 0.047UF JC107 CC73GCH1H471J CHIP C 470PF JC108 C92-0754-05 CHIP-TAN 4.7UF 20WV

C109,110 CC73GCH1H471J CHIP C 470PF JC111-113 CK73GB1C104K CHIP C 0.10UF KC114 CC73GCH1H471J CHIP C 470PF JC115 CK73GB1E473J CHIP C 0.047UF JC116 CK73GB1C104K CHIP C 0.10UF K

C117-119 CK73FB1C105K CHIP C 1.0UF KC120 CK73GB1E473J CHIP C 0.047UF JC121 CK73GB1H102K CHIP C 1000PF KC122,123 CK73GB1C104K CHIP C 0.10UF KC124-126 CC73GCH1H101J CHIP C 100PF J

C127 C92-0585-05 CHIP-TAN 4.7UF 16WVC128-131 C92-0628-05 CHIP-TAN 10UF 10WVC132 CK73GB1H102K CHIP C 1000PF KC133 C92-0585-05 CHIP-TAN 4.7UF 16WVC134 CK73FB1E224K CHIP C 0.22UF K

C135 C92-0628-05 CHIP-TAN 10UF 10WVC200 CK73GB1C104K CHIP C 0.10UF KC201 CK73FB1E224K CHIP C 0.22UF KC202 CK73GB1H102K CHIP C 1000PF KC203 CK73GB1C104K CHIP C 0.10UF K

C204,205 CK73GB1H102K CHIP C 1000PF KC206 CK73GB1H152K CHIP C 1500PF KC207 CK73GB1C104K CHIP C 0.10UF KC208,209 CC73GCH1H271J CHIP C 270PF JC210 CK73GB1H102K CHIP C 1000PF K



nationNewparts

TX-RX UNIT (X57-6570-10)

DISPLAY UNIT (X54-3400-10)

TX-RX UNIT (X57-6570-10)

TK-7150

25

PARTS LIST

C211 CK73GB1C104K CHIP C 0.10UF KC212 CK73GB1H103K CHIP C 0.010UF KC213 CC73GCH1H270J CHIP C 27PF JC214 CK73GB1C104K CHIP C 0.10UF KC215 C92-0560-05 CHIP-TAN 10UF 6.3WV

C216 CK73GB1C333K CHIP C 0.033UF KC217,218 CK73GB1H103K CHIP C 0.010UF KC219 C92-0560-05 CHIP-TAN 10UF 6.3WVC220 CK73GB1H103K CHIP C 0.010UF KC221 CC73GCH1H180J CHIP C 18PF J

C222 CC73GCH1H150J CHIP C 15PF JC223 CK73GB1H102K CHIP C 1000PF KC224 CK73GB1H103K CHIP C 0.010UF KC225 CK73GB1C104K CHIP C 0.10UF KC226 CC73GCH1H080D CHIP C 8.0PF D

C227 CC73GCH1H101J CHIP C 100PF JC228 CC73GCH1H100D CHIP C 10PF DC229,230 CK73GB1H103K CHIP C 0.010UF KC231,232 CC73GCH1H470J CHIP C 47PF JC233,234 CK73GB1H103K CHIP C 0.010UF K

C235,236 CC73GCH1H010C CHIP C 1.0PF CC237 CC73GCH1H101J CHIP C 100PF JC238,239 CC73GCH1H030C CHIP C 3.0PF CC240 CK73GB1H102K CHIP C 1000PF KC241,242 CC73GCH1H010C CHIP C 1.0PF C

C243,244 CK73GB1H103K CHIP C 0.010UF KC245,246 CC73GCH1H470J CHIP C 47PF JC247 CK73GB1H102K CHIP C 1000PF KC248 CC73GCH1H151J CHIP C 150PF JC249 CK73GB1H103K CHIP C 0.010UF K

C251 CC73GCH1H330J CHIP C 33PF JC252 CC73GCH1H101J CHIP C 100PF JC253 CK73GB1H103K CHIP C 0.010UF KC254 CC73GCH1H221J CHIP C 220PF JC255,256 CK73GB1H102K CHIP C 1000PF K

C257 CC73GCH1H680J CHIP C 68PF JC258 CC73GCH1H090D CHIP C 9.0PF DC259 CC73GCH1H150J CHIP C 15PF JC260 CC73GCH1H270J CHIP C 27PF JC261 CK73GB1H103K CHIP C 0.010UF K

C262 CC73GCH1H030C CHIP C 3.0PF CC263 CK73GB1C104K CHIP C 0.10UF KC264 CC73GCH1H270J CHIP C 27PF JC265 CC73GCH1H030C CHIP C 3.0PF CC266 CC73GCH1H150J CHIP C 15PF J

C267-269 CK73GB1H103K CHIP C 0.010UF KC270 CC73GCH1H050C CHIP C 5.0PF CC271 CK73GB1H102K CHIP C 1000PF KC272 CC73GCH1H270J CHIP C 27PF JC273 CC73GCH1H100D CHIP C 10PF D

C274 CC73GCH1H221J CHIP C 220PF JC276 CC73GCH1H270J CHIP C 27PF JC277 CK73GB1H103K CHIP C 0.010UF KC278 CC73GCH1H151J CHIP C 150PF JC279 CC73GCH1H270J CHIP C 27PF J

C280 CC73GCH1H100D CHIP C 10PF DC281,282 CC73GCH1H221J CHIP C 220PF JC283 CC73GCH1H270J CHIP C 27PF JC284 CK73GB1H103K CHIP C 0.010UF KC285 CK73GB1H102K CHIP C 1000PF K

C286 CC73GCH1H120J CHIP C 12PF JC287 CK73GB1H103K CHIP C 0.010UF KC288 CK73GB1H102K CHIP C 1000PF KC289 CC73GCH1H270J CHIP C 27PF JC290 CC73GCH1H100D CHIP C 10PF D

C291,292 CC73GCH1H221J CHIP C 220PF JC293 CC73GCH1H270J CHIP C 27PF JC294 CK73GB1H103K CHIP C 0.010UF KC295 CK73GB1H102K CHIP C 1000PF KC305 CK73GB1C104K CHIP C 0.10UF K

C306 C92-0712-05 CHIP-TAN 22UF 6.3WVC501 CK73GB1H102K CHIP C 1000PF KC502 C92-0514-05 CHIP-TAN 2.2UF 10WVC503 C92-0560-05 CHIP-TAN 10UF 6.3WVC504 CK73FB1E683K CHIP C 0.068UF K

C505,506 CK73GB1H102K CHIP C 1000PF KC507 C92-0502-05 CHIP-TAN 0.33UF 35WVC508 CK73GB1C104K CHIP C 0.10UF KC509 C92-0585-05 CHIP-TAN 4.7UF 16WVC510 CC73GCH1H100D CHIP C 10PF D

C512 CK73GB1H103K CHIP C 0.010UF KC513 C92-0585-05 CHIP-TAN 4.7UF 16WVC514 CK73GB1H102K CHIP C 1000PF KC515 CK73GB1C104K CHIP C 0.10UF KC516 CK73GB1H102K CHIP C 1000PF K

C517 CK73GB1C104K CHIP C 0.10UF KC519 CK73GB1H102K CHIP C 1000PF KC520 CK73FB1E224K CHIP C 0.22UF KC521 C92-0003-05 CHIP-TAN 0.47UF 25WVC522 CC73GCH1H471J CHIP C 470PF J

C523-525 CK73GB1C104K CHIP C 0.10UF KC526 CK73GB1H102K CHIP C 1000PF KC527 C92-0628-05 CHIP-TAN 10UF 10WVC528 CC73GCH1H150G CHIP C 15PF GC529 CC73GCH1H030B CHIP C 3.0PF B

C530 CK73GB1C104K CHIP C 0.10UF KC531 CC73GCH1H270G CHIP C 27PF GC532 CC73GCH1H680G CHIP C 68PF GC533 CC73GCH1H560G CHIP C 56PF GC534 CC73GCH1H030B CHIP C 3.0PF B

C535 CC73GCH1H150G CHIP C 15PF GC537 CK73GB1C104K CHIP C 0.10UF KC538 CC73GCH1H471J CHIP C 470PF JC539 CC73GCH1H150G CHIP C 15PF GC540 CC73GCH1H470G CHIP C 47PF G

C541 CC73GCH1H330G CHIP C 33PF GC542 CK73GB1C104K CHIP C 0.10UF KC543 CC73GCH1HR75B CHIP C 0.75PF BC544,545 CK73GB1H102K CHIP C 1000PF KC546,547 CC73GCH1H090B CHIP C 9.0PF B

C548,549 CC73GCH1H150G CHIP C 15PF GC550 CK73GB1H102K CHIP C 1000PF KC551 CC73GCH1H150G CHIP C 15PF GC552,553 CK73GB1H102K CHIP C 1000PF KC554 CC73GCH1H010B CHIP C 1.0PF B

C555 CK73GB1H102K CHIP C 1000PF KC556 CC73GCH1H010B CHIP C 1.0PF BC557 CK73GB1H103K CHIP C 0.010UF KC559 CK73GB1H102K CHIP C 1000PF KC560,561 C90-4085-05 ELECTRO CAP 47UF 20WV



nationNewparts

TX-RX UNIT (X57-6570-10)

TK-7150

26

PARTS LIST

C562 CK73GB1H102K CHIP C 1000PF KC563 CK73GB1H103K CHIP C 0.010UF KC564 CC73GCH1H150J CHIP C 15PF JC565 CK73GB1H102K CHIP C 1000PF KC567-573 CK73GB1H102K CHIP C 1000PF K

C574 CK73GB1H103K CHIP C 0.010UF KC575 CC73GCH1H150J CHIP C 15PF JC576 C92-0633-05 CHIP-TAN 22UF 10WVC577 CC73GCH1H150J CHIP C 15PF JC578 CK73GB1H102K CHIP C 1000PF K

C579 C92-0696-05 CHIP-TAN 47UF 10WVC580 CK73GB1H102K CHIP C 1000PF KC581 CK73GB1H103K CHIP C 0.010UF KC584 C92-0606-05 CHIP-TAN 4.7UF 10WVC585-587 CK73GB1H102K CHIP C 1000PF K

C593 CK73FB1E683K CHIP C 0.068UF KC594 CK73GB1H102K CHIP C 1000PF KC700,701 CK73GB1H103K CHIP C 0.010UF KC702 CK73GB1C104K CHIP C 0.10UF KC703 CC73GCH1H030C CHIP C 3.0PF C

C704,705 CC73GCH1H220J CHIP C 22PF JC706-708 CK73GB1H103K CHIP C 0.010UF KC709,710 C92-0519-05 CHIP-TAN 1.0UF 25WVC711 CK73FB1C105K CHIP C 1.0UF KC712,713 C92-0519-05 CHIP-TAN 1.0UF 25WV

C714 CK73GB1C104K CHIP C 0.10UF KC715 CK73FB1C105K CHIP C 1.0UF KC716 CK73GB1H103K CHIP C 0.010UF KC717,718 CK73GB1C104K CHIP C 0.10UF KC719-721 CK73FB1C105K CHIP C 1.0UF K

C722-724 CK73GB1H103K CHIP C 0.010UF KC725 CK73FB1C105K CHIP C 1.0UF KC726 CK73GB1H103K CHIP C 0.010UF KC727 CK73FB1C105K CHIP C 1.0UF KC728 CK73GB1H103K CHIP C 0.010UF K

C729 CK73GB1H102K CHIP C 1000PF KC730,731 CC73GCH1H101J CHIP C 100PF JC732,733 CK73GB1H102K CHIP C 1000PF KC734 CC73GCH1H101J CHIP C 100PF JC735,736 CK73GB1H102K CHIP C 1000PF K

C737 CC73GCH1H101J CHIP C 100PF JC738 CK73GB1H102K CHIP C 1000PF KC739 CK73FB1C105K CHIP C 1.0UF KC740 CK73GB1H102K CHIP C 1000PF KC741 CK73GB1H103K CHIP C 0.010UF K

C742 CK73GB1H102K CHIP C 1000PF KC743 CK73GB1C104K CHIP C 0.10UF KC744 CC73GCH1H101J CHIP C 100PF JC745 CK73FB1C105K CHIP C 1.0UF KC746 CC73GCH1H101J CHIP C 100PF J

C747 CK73GB1H103K CHIP C 0.010UF KC748 CC73GCH1H101J CHIP C 100PF JC749 CK73GB1H102K CHIP C 1000PF KC750 CK73FB1C105K CHIP C 1.0UF KC751-755 CK73GB1H103K CHIP C 0.010UF K

C756-759 CK73FB1C105K CHIP C 1.0UF KC760 CC73GCH1H471J CHIP C 470PF JC761 CC73GCH1H220J CHIP C 22PF JC762 CK73GB1H103K CHIP C 0.010UF KC764,765 C92-0501-05 CHIP-TAN 1.5UF 10WV

C766 CC73GCH1H151J CHIP C 150PF JC767 C92-0628-05 CHIP-TAN 10UF 10WVC768,769 CK73GB1C104K CHIP C 0.10UF KC770 C92-0712-05 CHIP-TAN 22UF 6.3WVC771,772 C92-0628-05 CHIP-TAN 10UF 10WV

C773 CC73GCH1H470J CHIP C 47PF JC774 CK73GB1C104K CHIP C 0.10UF KC775,776 CK73GB1H103K CHIP C 0.010UF KC777 CK73GB1C104K CHIP C 0.10UF KC778 C92-0628-05 CHIP-TAN 10UF 10WV

C779,780 CC73GCH1H101J CHIP C 100PF JC781,782 C92-0712-05 CHIP-TAN 22UF 6.3WVC784 CC73GCH1H390J CHIP C 39PF JC785 C92-0712-05 CHIP-TAN 22UF 6.3WVC787 CK73GB1H102K CHIP C 1000PF K

C788 C92-0628-05 CHIP-TAN 10UF 10WVC789 CK73GB1H102K CHIP C 1000PF KC790 CK73GB1H103K CHIP C 0.010UF KC793 CC73GCH1H330J CHIP C 33PF JC794 C92-0628-05 CHIP-TAN 10UF 10WV

C795 C92-0712-05 CHIP-TAN 22UF 6.3WVC796 CK73GB1H152K CHIP C 1500PF KC797-799 CK73GB1H103K CHIP C 0.010UF KC800,801 C92-0712-05 CHIP-TAN 22UF 6.3WVC802 CC73GCH1H680J CHIP C 68PF J

C803 CK73GB1H122K CHIP C 1200PF KC804 CK73GB1H102K CHIP C 1000PF KC805 C92-0712-05 CHIP-TAN 22UF 6.3WVC806,807 CK73GB1H103K CHIP C 0.010UF KC808 C92-0628-05 CHIP-TAN 10UF 10WV

C809 C92-0719-05 ELECTRO CAP 47UF 25WVC810 CK73GB1H102K CHIP C 1000PF KC811 CC73GCH1H101J CHIP C 100PF JC812 C90-2146-05 ELECTRO 100UF 25WVC813 CK73GB1C104K CHIP C 0.10UF K

C814 CK73GB1H103K CHIP C 0.010UF KC815,816 CK73GB1C104K CHIP C 0.10UF KC817 CK73GB1H103K CHIP C 0.010UF KC819 C92-0719-05 ELECTRO CAP 47UF 25WVC820 CK73GB1H103K CHIP C 0.010UF K

C822 CK73GB1C104K CHIP C 0.10UF KC823 CC73GCH1H101J CHIP C 100PF JC825-830 CK73GB1H102K CHIP C 1000PF KC831 CK73GB1C104K CHIP C 0.10UF KC832 CC73GCH1H101J CHIP C 100PF J

C833 CK73GB1C104K CHIP C 0.10UF KC834 CK73GB1H103K CHIP C 0.010UF KC835 CC73GCH1H470J CHIP C 47PF JC836 C92-0628-05 CHIP-TAN 10UF 10WVC837,838 CK73GB1C104K CHIP C 0.10UF K

C844 CK73GB1H102K CHIP C 1000PF KC845 C92-0628-05 CHIP-TAN 10UF 10WVC846 CK73GB1H102K CHIP C 1000PF KTC501,502 C05-0396-05 CERAMIC TRIMMER CAP (8P)

CN102 E23-1233-04 TERMINALCN201-203 E40-5538-05 PIN ASSYCN700,701 E40-9370-05 PIN ASSYCN703 E40-5176-05 PIN ASSYCN704 E40-3241-05 PIN ASSY



nationNewparts

TX-RX UNIT (X57-6570-10)

TK-7150

27

PARTS LIST

CN731-756 E23-1081-05 TERMINALJ700 E58-0494-05 SUB SOCKET (D)

F100 F53-0278-05 FUSE

CF201 L72-1002-05 CERAMIC FILTERCF202 L72-0372-05 CERAMIC FILTERCF203 L72-1002-05 CERAMIC FILTERCF204 L72-0372-05 CERAMIC FILTERL2,3 L40-6875-92 SMALL FIXED INDUCTOR (68NH)

L4 L41-2775-20 SMALL FIXED INDUCTORL5 L41-1875-20 SMALL FIXED INDUCTORL6 L34-4520-05 AIR-CORE COILL7 L34-4602-05 AIR-CORE COILL8 L34-4520-05 AIR-CORE COIL

L9 L34-4518-05 AIR-CORE COILL10 L34-4523-05 AIR-CORE COILL11-14 L34-4520-05 AIR-CORE COILL15 L34-4523-05 AIR-CORE COILL16,17 L40-5675-92 SMALL FIXED INDUCTOR (56NH)

L201 L34-4530-05 COILL202,203 L40-1095-34 SMALL FIXED INDUCTOR (1UH)L204 L40-1005-34 SMALL FIXED INDUCTOR (10UH)L205 L34-4526-05 COILL206 L34-4527-05 COIL

L207 L34-4526-05 COILL208 L34-4527-05 COILL209 L34-4526-05 COILL210 L34-4527-05 COILL211 L40-1005-34 SMALL FIXED INDUCTOR (10UH)

L212 L40-3381-37 SMALL FIXED INDUCTOR (0.330UH)L213 L40-1281-37 SMALL FIXED INDUCTOR (0.120UH)L214 L40-3975-34 SMALL FIXED INDUCTOR (39NH)L215 L40-1885-34 SMALL FIXED INDUCTOR (180NH)L216,217 L40-3375-34 SMALL FIXED INDUCTOR (33NH)

L218 L39-1272-05 TOROIDAL COILL219 L40-6895-34 SMALL FIXED INDUCTOR (6.8UH)L220 L40-3375-34 SMALL FIXED INDUCTOR (33NH)L221,222 L39-1272-05 TOROIDAL COILL223 L40-1005-34 SMALL FIXED INDUCTOR (10UH)

L224 L40-8271-34 SMALL FIXED INDUCTOR (82NH)L225 L40-1085-34 SMALL FIXED INDUCTOR (100NH)L501 L92-0138-05 FERRITE CHIPL503 L40-5695-34 SMALL FIXED INDUCTOR (5.6UH)L504 L41-3398-08 SMALL FIXED INDUCTOR

L505 L41-2798-08 SMALL FIXED INDUCTORL506 L40-3975-92 SMALL FIXED INDUCTOR (39NH)L507 L41-3398-08 SMALL FIXED INDUCTORL508 L41-2798-08 SMALL FIXED INDUCTORL509 L40-3975-92 SMALL FIXED INDUCTOR (39NH)

L510 L34-4610-05 AIR-CORE COILL511 L34-4612-05 AIR-CORE COILL512,513 L40-1015-34 SMALL FIXED INDUCTOR (100UH)L514 L41-2798-08 SMALL FIXED INDUCTORL515 L41-3398-08 SMALL FIXED INDUCTOR

L516 L41-2798-08 SMALL FIXED INDUCTORL517 L40-1085-92 SMALL FIXED INDUCTOR (100NH)L519 L40-8275-92 SMALL FIXED INDUCTOR (82NH)L520 L40-1085-92 SMALL FIXED INDUCTOR (100NH)L700,701 L92-0138-05 FERRITE CHIP

L703 L92-0138-05 FERRITE CHIPL704-713 L92-0140-05 FERRITE CHIPX201 L77-1762-05 CRYSTAL RESONATOR (44.395MHZ)X501 L77-1902-05 VCXO (16.8MHZ/2.5PP)X700 L77-1896-05 CRYSTAL RESONATOR (12.288MHZ)

XF201 L71-0512-05 MCF (44.85MHZ WIDE)XF202 L71-0513-05 MCF (44.85MHZ NARR)

CP700-715 R90-0740-05 MULTIPLE RESISTORR1 RK73GB1J102J CHIP R 1.0K J 1/16WR2 RK73GB1J180J CHIP R 18 J 1/16WR4 RK73GB1J100J CHIP R 10 J 1/16WR5 RK73GB1J472J CHIP R 4.7K J 1/16W

R6 RK73GB1J471J CHIP R 470 J 1/16WR7 RK73GB1J470J CHIP R 47 J 1/16WR9 RK73GB1J220J CHIP R 22 J 1/16WR10 RK73GB1J222J CHIP R 2.2K J 1/16WR11 RK73GB1J101J CHIP R 100 J 1/16W

R12 RK73FB2A100J CHIP R 10 J 1/10WR13 RK73FB2A180J CHIP R 18 J 1/10WR14 R92-1252-05 CHIP R 0 OHM J 1/16WR15 RK73FB2A180J CHIP R 18 J 1/10WR16 R92-3513-05 RESISTOR 0.003 1W

R17,18 RK73GB1J104J CHIP R 100K J 1/16WR19,20 RK73GB1J563J CHIP R 56K J 1/16WR21 RK73FB2A101J CHIP R 100 J 1/10WR22 RK73GB1J154J CHIP R 150K J 1/16WR23 RK73GB1J104J CHIP R 100K J 1/16W

R24 RK73GB1J103J CHIP R 10K J 1/16WR26 R92-1252-05 CHIP R 0 OHM J 1/16WR27 RK73GB1J474J CHIP R 470K J 1/16WR28 RK73GB1J103J CHIP R 10K J 1/16WR29 R92-1252-05 CHIP R 0 OHM J 1/16W

R31 RK73GB1J101J CHIP R 100 J 1/16WR32,33 RK73GB1J104J CHIP R 100K J 1/16WR34 RK73EB2B101J CHIP R 100 J 1/8WR36 RK73GB1J334J CHIP R 330K J 1/16WR37 RK73GB1J104J CHIP R 100K J 1/16W

R38,39 RK73GB1J103J CHIP R 10K J 1/16WR40,41 R92-1252-05 CHIP R 0 OHM J 1/16WR42,43 RK73GB1J104J CHIP R 100K J 1/16WR44 R92-1214-05 CHIP R 120 J 1/2WR45-47 RK73GB1J473J CHIP R 47K J 1/16W

R48,49 RK73GB1J271J CHIP R 270 J 1/16WR50 RK73GB1J681J CHIP R 680 J 1/16WR51,52 RK73GB1J102J CHIP R 1.0K J 1/16WR53 RK73GB1J471J CHIP R 470 J 1/16WR54,55 RK73FB2A271J CHIP R 270 J 1/10W

R56 R92-1252-05 CHIP R 0 OHM J 1/16WR58 RK73GB1J104J CHIP R 100K J 1/16WR59 R92-1061-05 JUMPER REST 0 OHMR101 RK73GB1J474J CHIP R 470K J 1/16WR102 RK73GB1J394J CHIP R 390K J 1/16W

R103 RK73GB1J471J CHIP R 470 J 1/16WR104,105 RK73GB1J334J CHIP R 330K J 1/16WR106 RK73GB1J472J CHIP R 4.7K J 1/16WR107-109 RK73GB1J473J CHIP R 47K J 1/16WR110,111 RK73GB1J472J CHIP R 4.7K J 1/16W

R112 RK73GB1J102J CHIP R 1.0K J 1/16WR113 RK73GB1J104J CHIP R 100K J 1/16W



nationNewparts

TX-RX UNIT (X57-6570-10)

TK-7150

28

PARTS LIST

R114 RK73GB1J473J CHIP R 47K J 1/16WR115 RK73GB1J104J CHIP R 100K J 1/16WR116 RK73GB1J473J CHIP R 47K J 1/16WR117 RK73GB1J103J CHIP R 10K J 1/16WR118 RK73GB1J104J CHIP R 100K J 1/16W

R119 RK73GB1J102J CHIP R 1.0K J 1/16WR120 RK73GB1J103J CHIP R 10K J 1/16WR121 RK73GB1J333J CHIP R 33K J 1/16WR122 RK73GB1J472J CHIP R 4.7K J 1/16WR123 RK73GB1J102J CHIP R 1.0K J 1/16W

R124 RK73GB1J333J CHIP R 33K J 1/16WR125 RK73GB1J473J CHIP R 47K J 1/16WR126 R92-1252-05 CHIP R 0 OHM J 1/16WR200 RK73GB1J563J CHIP R 56K J 1/16WR202 RK73GB1J393J CHIP R 39K J 1/16W

R203 RK73GB1J334J CHIP R 330K J 1/16WR204,205 RK73GB1J332J CHIP R 3.3K J 1/16WR206 RK73GB1J152J CHIP R 1.5K J 1/16WR207 RK73GB1J560J CHIP R 56 J 1/16WR208 RK73GB1J472J CHIP R 4.7K J 1/16W

R209 RK73GB1J334J CHIP R 330K J 1/16WR210 RK73GB1J222J CHIP R 2.2K J 1/16WR211 RK73GB1J332J CHIP R 3.3K J 1/16WR212 RK73GB1J274J CHIP R 270K J 1/16WR213 RK73GB1J273J CHIP R 27K J 1/16W

R214 RK73GB1J153J CHIP R 15K J 1/16WR215 RK73GB1J682J CHIP R 6.8K J 1/16WR216,217 RK73GB1J223J CHIP R 22K J 1/16WR218 RK73GB1J102J CHIP R 1.0K J 1/16WR219 RK73GB1J682J CHIP R 6.8K J 1/16W

R220 RK73GB1J223J CHIP R 22K J 1/16WR221 RK73GB1J153J CHIP R 15K J 1/16WR222 RK73GB1J103J CHIP R 10K J 1/16WR223 RK73GB1J220J CHIP R 22 J 1/16WR224 RK73GB1J101J CHIP R 100 J 1/16W

R225 RK73GB1J102J CHIP R 1.0K J 1/16WR226 RK73GB1J473J CHIP R 47K J 1/16WR227-229 RK73GB1J222J CHIP R 2.2K J 1/16WR230 RK73GB1J102J CHIP R 1.0K J 1/16WR231-233 RK73GB1J222J CHIP R 2.2K J 1/16W

R234 R92-1252-05 CHIP R 0 OHM J 1/16WR235 RK73GB1J560J CHIP R 56 J 1/16WR236 RK73GB1J270J CHIP R 27 J 1/16WR237 RK73GB1J682J CHIP R 6.8K J 1/16WR238 RK73GB1J102J CHIP R 1.0K J 1/16W

R239 R92-1252-05 CHIP R 0 OHM J 1/16WR240 RK73GB1J182J CHIP R 1.8K J 1/16WR241 RK73GB1J103J CHIP R 10K J 1/16WR242 RK73GB1J472J CHIP R 4.7K J 1/16WR243 RK73GB1J102J CHIP R 1.0K J 1/16W

R244 RK73GB1J330J CHIP R 33 J 1/16WR245 RK73GB1J220J CHIP R 22 J 1/16WR246 RK73GB1J470J CHIP R 47 J 1/16WR247 RK73GB1J821J CHIP R 820 J 1/16WR248 RK73GB1J5R6J CHIP R 5.6 J 1/16W

R249,250 RK73GB1J821J CHIP R 820 J 1/16WR251 RK73GB1J5R6J CHIP R 5.6 J 1/16WR252 RK73GB1J821J CHIP R 820 J 1/16WR253 RK73GB1J101J CHIP R 100 J 1/16WR254,255 RK73GB1J100J CHIP R 10 J 1/16W

R256 RK73GB1J103J CHIP R 10K J 1/16WR257,258 RK73GB1J100J CHIP R 10 J 1/16WR259 RK73GB1J101J CHIP R 100 J 1/16WR260,261 RK73GB1J103J CHIP R 10K J 1/16WR262,263 RK73GB1J271J CHIP R 270 J 1/16W

R264 R92-1252-05 CHIP R 0 OHM J 1/16WR265 RK73GB1J102J CHIP R 1.0K J 1/16WR266,267 RK73GB1J104J CHIP R 100K J 1/16WR268 RK73GB1J221J CHIP R 220 J 1/16WR269 RK73GB1J470J CHIP R 47 J 1/16W

R270 RK73GB1J120J CHIP R 12 J 1/16WR271 RK73GB1J473J CHIP R 47K J 1/16WR272 RK73GB1J472J CHIP R 4.7K J 1/16WR273 RK73GB1J102J CHIP R 1.0K J 1/16WR274 RK73GB1J104J CHIP R 100K J 1/16W

R276 R92-1252-05 CHIP R 0 OHM J 1/16WR284,285 RK73GB1J221J CHIP R 220 J 1/16WR286 RK73GB1J224J CHIP R 220K J 1/16WR287 RK73GB1J683J CHIP R 68K J 1/16WR288 RK73GB1J154J CHIP R 150K J 1/16W

R289 R92-0670-05 CHIP R 0 OHMR501 RK73GB1J220J CHIP R 22 J 1/16WR502 RK73GB1J221J CHIP R 220 J 1/16WR503 RK73GB1J561J CHIP R 560 J 1/16WR504 RK73GB1J102J CHIP R 1.0K J 1/16W

R505 RK73GB1J100J CHIP R 10 J 1/16WR506 R92-0670-05 CHIP R 0 OHMR507-509 RK73GB1J100J CHIP R 10 J 1/16WR510 RK73GB1J104J CHIP R 100K J 1/16WR511 RK73GB1J103J CHIP R 10K J 1/16W

R512 RK73GB1J474J CHIP R 470K J 1/16WR513 R92-1252-05 CHIP R 0 OHM J 1/16WR514 RK73GB1J470J CHIP R 47 J 1/16WR515 R92-2072-05 CHIP R 1.5K J 1/2WR516 RK73GB1J473J CHIP R 47K J 1/16W

R517 RK73GB1J100J CHIP R 10 J 1/16WR518 RK73GB1J272J CHIP R 2.7K J 1/16WR519 RK73GB1J100J CHIP R 10 J 1/16WR520 RK73GB1J151J CHIP R 150 J 1/16WR521 RK73GB1J561J CHIP R 560 J 1/16W

R522 RK73GB1J220J CHIP R 22 J 1/16WR523 RK73GB1J560J CHIP R 56 J 1/16WR524 R92-1252-05 CHIP R 0 OHM J 1/16WR525 RK73GB1J102J CHIP R 1.0K J 1/16WR526 R92-1252-05 CHIP R 0 OHM J 1/16W


R532 RK73GB1J104J CHIP R 100K J 1/16WR533 RK73GB1J152J CHIP R 1.5K J 1/16WR534,535 RK73GB1J102J CHIP R 1.0K J 1/16WR536 RK73GB1J391J CHIP R 390 J 1/16WR537 RK73GB1J221J CHIP R 220 J 1/16W

R538 RK73GB1J100J CHIP R 10 J 1/16WR539,540 RK73GB1J101J CHIP R 100 J 1/16WR541 RK73GB1J152J CHIP R 1.5K J 1/16WR542,543 RK73GB1J472J CHIP R 4.7K J 1/16WR544 RK73GB1J224J CHIP R 220K J 1/16W



nationNewparts

TX-RX UNIT (X57-6570-10)

TK-7150

29

PARTS LIST

R546 RK73GB1J330J CHIP R 33 J 1/16WR547 RK73GB1J472J CHIP R 4.7K J 1/16WR548 RK73GB1J103J CHIP R 10K J 1/16WR549 RK73GB1J472J CHIP R 4.7K J 1/16WR550 R92-1252-05 CHIP R 0 OHM J 1/16W

R551 RK73GB1J331J CHIP R 330 J 1/16WR553 RK73GB1J101J CHIP R 100 J 1/16WR554 RK73GB1J470J CHIP R 47 J 1/16WR555 RK73GB1J333J CHIP R 33K J 1/16WR556,557 RK73GB1J103J CHIP R 10K J 1/16W

R558 RK73GB1J472J CHIP R 4.7K J 1/16WR559 RK73GB1J101J CHIP R 100 J 1/16WR560 RK73GB1J100J CHIP R 10 J 1/16WR561 RK73GB1J152J CHIP R 1.5K J 1/16WR562 RK73GB1J331J CHIP R 330 J 1/16W

R563 RK73GB1J221J CHIP R 220 J 1/16WR564 RK73GB1J101J CHIP R 100 J 1/16WR565 RK73GB1J331J CHIP R 330 J 1/16WR566 RK73GB1J330J CHIP R 33 J 1/16WR567 RK73GB1J222J CHIP R 2.2K J 1/16W

R568 RK73GB1J104J CHIP R 100K J 1/16WR569 RK73GB1J103J CHIP R 10K J 1/16WR570 RK73GB1J104J CHIP R 100K J 1/16WR571 RK73GB1J103J CHIP R 10K J 1/16WR572 RK73GB1J272J CHIP R 2.7K J 1/16W

R573 RK73GB1J103J CHIP R 10K J 1/16WR700 RK73GB1J102J CHIP R 1.0K J 1/16WR701 RK73GB1J473J CHIP R 47K J 1/16WR702 RK73GB1J472J CHIP R 4.7K J 1/16WR703 R92-1252-05 CHIP R 0 OHM J 1/16W

R704 RK73GB1J473J CHIP R 47K J 1/16WR705,706 RK73GB1J152J CHIP R 1.5K J 1/16WR707,708 RK73GB1J333J CHIP R 33K J 1/16WR709,710 RK73GB1J473J CHIP R 47K J 1/16WR711 RK73HB1J101J CHIP R 100 J 1/16W

R713 RK73GB1J473J CHIP R 47K J 1/16WR715 RK73GB1J473J CHIP R 47K J 1/16WR718 RK73GB1J473J CHIP R 47K J 1/16WR726,727 RK73GB1J473J CHIP R 47K J 1/16WR728-731 R92-1252-05 CHIP R 0 OHM J 1/16W

R749 RK73GB1J473J CHIP R 47K J 1/16WR751 R92-1252-05 CHIP R 0 OHM J 1/16WR752,753 RK73GB1J473J CHIP R 47K J 1/16WR754 R92-1252-05 CHIP R 0 OHM J 1/16WR755,756 RK73GB1J102J CHIP R 1.0K J 1/16W

R757 RK73GB1J473J CHIP R 47K J 1/16WR758 R92-1252-05 CHIP R 0 OHM J 1/16WR759 RK73GB1J473J CHIP R 47K J 1/16WR760 RK73GB1J102J CHIP R 1.0K J 1/16WR761 RK73GB1J473J CHIP R 47K J 1/16W

R762 RK73GB1J102J CHIP R 1.0K J 1/16WR763,764 RK73GB1J473J CHIP R 47K J 1/16WR765 RK73GB1J102J CHIP R 1.0K J 1/16WR766 RK73GB1J472J CHIP R 4.7K J 1/16WR767,768 RK73GB1J473J CHIP R 47K J 1/16W

R769 RK73GB1J101J CHIP R 100 J 1/16WR770 RK73GB1J473J CHIP R 47K J 1/16WR771 RK73GB1J102J CHIP R 1.0K J 1/16WR772 RK73GB1J473J CHIP R 47K J 1/16WR773 RK73GB1J102J CHIP R 1.0K J 1/16W

R774 RK73GB1J472J CHIP R 4.7K J 1/16WR775-777 RK73GB1J473J CHIP R 47K J 1/16WR778 RK73GB1J102J CHIP R 1.0K J 1/16WR779,780 RK73GB1J473J CHIP R 47K J 1/16WR781 RK73GB1J223J CHIP R 22K J 1/16W

R782 RK73GB1J104J CHIP R 100K J 1/16WR783 RK73GB1J473J CHIP R 47K J 1/16WR784 RK73GB1J681J CHIP R 680 J 1/16WR785 RK73GB1J224J CHIP R 220K J 1/16WR786 RK73GB1J684J CHIP R 680K J 1/16W

R787 R92-1252-05 CHIP R 0 OHM J 1/16WR788 RK73GB1J683J CHIP R 68K J 1/16WR789 RK73GB1J183J CHIP R 18K J 1/16WR793 RK73GB1J102J CHIP R 1.0K J 1/16WR794 RK73GB1J392J CHIP R 3.9K J 1/16W

R795 RK73GB1J124J CHIP R 120K J 1/16WR797 RK73GB1J563J CHIP R 56K J 1/16WR798 R92-0670-05 CHIP R 0 OHMR799 RK73GB1J103J CHIP R 10K J 1/16WR800 RK73GB1J224J CHIP R 220K J 1/16W

R801,802 RK73GB1J473J CHIP R 47K J 1/16WR803 RK73GB1J274J CHIP R 270K J 1/16WR804 RK73GB1J104J CHIP R 100K J 1/16WR805 RK73GB1J103J CHIP R 10K J 1/16WR806,807 RK73GB1J473J CHIP R 47K J 1/16W

R808 RK73GB1J823J CHIP R 82K J 1/16WR810 RK73GB1J154J CHIP R 150K J 1/16WR811,812 RK73GB1J104J CHIP R 100K J 1/16WR813 RK73GB1J153J CHIP R 15K J 1/16WR814 RK73GB1J103J CHIP R 10K J 1/16W

R815,816 RK73GB1J473J CHIP R 47K J 1/16WR817,818 RK73GB1J104J CHIP R 100K J 1/16WR819 RK73GB1J563J CHIP R 56K J 1/16WR820 RK73GB1J333J CHIP R 33K J 1/16WR821 RK73GB1J473J CHIP R 47K J 1/16W

R822 RK73GB1J102J CHIP R 1.0K J 1/16WR823 RK73GB1J224J CHIP R 220K J 1/16WR824 RK73GB1J153J CHIP R 15K J 1/16WR825 RK73GB1J473J CHIP R 47K J 1/16WR826 RK73GB1J103J CHIP R 10K J 1/16W

R827 R92-0670-05 CHIP R 0 OHMR828 RK73GB1J103J CHIP R 10K J 1/16WR829 RK73GB1J102J CHIP R 1.0K J 1/16WR831 RK73GB1J104J CHIP R 100K J 1/16WR832 RK73GB1J473J CHIP R 47K J 1/16W


R839 RK73GB1J104J CHIP R 100K J 1/16WR841 RK73GB1J104J CHIP R 100K J 1/16WR842 R92-1252-05 CHIP R 0 OHM J 1/16WR843-846 RK73GB1J473J CHIP R 47K J 1/16WR847 RK73GB1J124J CHIP R 120K J 1/16W

R848 RK73GB1J334J CHIP R 330K J 1/16WR849 RK73GB1J102J CHIP R 1.0K J 1/16WR850 RK73GB1J103J CHIP R 10K J 1/16WR851,852 R92-1252-05 CHIP R 0 OHM J 1/16WR853 RK73GB1J104J CHIP R 100K J 1/16W



nationNewparts

TX-RX UNIT (X57-6570-10)

TK-7150

30

PARTS LIST

R854 RK73GB1J474J CHIP R 470K J 1/16WR857 RK73GB1J103J CHIP R 10K J 1/16WR858 RK73GB1J473J CHIP R 47K J 1/16WR859 RK73GB1J333J CHIP R 33K J 1/16WR861,862 RK73GB1J473J CHIP R 47K J 1/16W

R863 RK73GB1J683J CHIP R 68K J 1/16WR864,865 RK73GB1J103J CHIP R 10K J 1/16WR866 R92-0670-05 CHIP R 0 OHMR867,868 R92-1252-05 CHIP R 0 OHM J 1/16WVR1 R12-6427-05 TRIMMING POT. (47K)

VR700 R32-0643-05 SEMI FIXED VARIABLE RESISTOR

K700 S76-0434-05 RELAY

D1 ZSA5A27 ZENER DIODED2 02DZ6.2(Y) ZENER DIODED3 MA4PH633 DIODED4 XB15A709 DIODED5,6 MA742 DIODE

D7 1SS226 DIODED11 1SS355 DIODED101 DSA3A1-FK DIODED102 02DZ18(X,Y) ZENER DIODED103 02DZ15(X,Y) ZENER DIODE

D104-106 1SS355 DIODED108 DA204U DIODED109 02DZ10(Z) ZENER DIODED201 1SS355 DIODED202 MA742 DIODE

D203-206 DAN235E DIODED207-209 1SV228 VARIABLE CAPACITANCE DIODED501-508 1SV282 VARIABLE CAPACITANCE DIODED509,510 1SS388 DIODED511 1SV278 VARIABLE CAPACITANCE DIODE

D512 02DZ12(Y) ZENER DIODED513,514 HVC131 DIODED515 MA2S111 DIODED700 1SS355 DIODED701-703 DA204U DIODE

D704 MA2S111 DIODED705-709 DA204U DIODED710 02DZ18(X,Y) ZENER DIODED711,712 MA742 DIODED714 1SS388 DIODE

D715 02DZ18(X,Y) ZENER DIODED785-790 02DZ5.1(Y) ZENER DIODED791 MINISMDM075/24 VARISTORD793 MINISMDM110/16 VARISTORIC1,2 TA75W01FU MOS IC

IC101 PST9140NR MOS ICIC102 TC4013BF(N) MOS ICIC103 PST9140NR MOS ICIC104 TA7808S MOS ICIC105 TA7805F MOS IC

IC106 XC62FP3302P MOS ICIC107 XC62FP1802P MOS ICIC108 XC62FP3302P MOS ICIC201 TA31136FN MOS ICIC202 TC7S66FU MOS IC

IC501 ADF4111BRU MOS IC

IC700 BU4094BCFV MOS ICIC701 30620M8A-5H1GP MPUIC702 BU4094BCFV MOS ICIC703 ADM202EARN MOS ICIC704 AT24128N10SI27 ROM IC

IC705 AT29C040A-12TI ROM ICIC706 TC74LVX4245FS MOS ICIC707-709 TC7WH32FK MOS ICIC710 320VC5402PGE MPUIC711 TC7SU04FU MOS IC

IC712 TA75W01FU MOS ICIC713 AK4550VT MOS ICIC714 TC75W51FU MOS ICIC715,716 TA75W01FU MOS ICIC717 BU4053BCFV MOS IC

IC718 M62364FP MOS ICIC719 TC75W51FU MOS ICIC720 TDA8561Q BI-POLAR ICIC721 LMC7101BIM5 MOS ICIC722 TA75S01F MOS IC

IC723 NJM78L05UA BI-POLAR ICIC724 TC4W53FU MOS ICIC725 PST9140NR MOS ICQ1 2SC3356(R24) TRANSISTORQ2 2SC3357 TRANSISTOR

Q4 PD55003S FETQ5 RD70HVF1-01 FETQ101,102 DTC114EE DIGITAL TRANSISTORQ103 2SJ506(S) FETQ104,105 DTC114EE DIGITAL TRANSISTOR

Q106,107 2SB1132(Q,R) TRANSISTORQ108 DTA114EE DIGITAL TRANSISTORQ109 DTA114YE DIGITAL TRANSISTORQ110 DTC114TE DIGITAL TRANSISTORQ111 DTA114EE DIGITAL TRANSISTOR

Q112 DTA114YE DIGITAL TRANSISTORQ113 DTC114YE DIGITAL TRANSISTORQ201 DTA114EE DIGITAL TRANSISTORQ202,203 DTC114EE DIGITAL TRANSISTORQ204 2SC4617(S) TRANSISTOR

Q205 DTA144EE DIGITAL TRANSISTORQ206 2SC4215(Y) TRANSISTORQ207,208 2SC3357 TRANSISTORQ209-212 2SK508NV(K52) FETQ213 2SC3357 TRANSISTOR

Q501 2SC4116(BL) TRANSISTORQ502 2SK1215(E) FETQ503,504 2SC4116(BL) TRANSISTORQ505 2SC4738(GR) TRANSISTORQ506 2SA1832(GR) TRANSISTOR

Q507 2SK508NV(K52) FETQ508 2SC4116(GR) TRANSISTORQ509 2SK508NV(K52) FETQ510-512 2SC4116(GR) TRANSISTORQ513 2SC5108(Y) TRANSISTOR

Q514 DTC114EE DIGITAL TRANSISTORQ515,516 2SC5108(Y) TRANSISTORQ517 2SC4116(GR) TRANSISTORQ518 2SA1832(GR) TRANSISTORQ519 DTC144EE DIGITAL TRANSISTOR



nationNewparts

TX-RX UNIT (X57-6570-10)

TK-7150

31

PARTS LIST

Q520 2SC4116(GR) TRANSISTORQ521 DTC144EE DIGITAL TRANSISTORQ700 2SK1824 FETQ701 DTC114EE DIGITAL TRANSISTORQ702 DTC144EE DIGITAL TRANSISTOR

Q703-706 DTD114EK DIGITAL TRANSISTORQ707 2SC4116(Y) TRANSISTORQ708 2SA1586(Y,GR) TRANSISTORQ709 DTC144EE DIGITAL TRANSISTORQ710 DTC114EE DIGITAL TRANSISTOR

Q711 2SD1757K TRANSISTORQ712 2SJ243 FETQ713 2SK1824 FETQ714 DTC144EE DIGITAL TRANSISTORQ716 DTC114EE DIGITAL TRANSISTOR

Q719,720 DTC114YE DIGITAL TRANSISTORTH1,2 S1R104J475H THERMISTORTH201 157-503-53006 THERMISTORTH202 157-104-65001 THERMISTOR



nationNewparts

TX-RX UNIT (X57-6570-10)

TK-7150

32

EXPLODED VIEWA B

1

2

3

Black

Red

1

28

26

2727

25

25

22 36

23

19

25

14

30

12

15

8

29

613

101

W1S1

41

1145

4031

4031

2

48 (A/2)

48 (B/2)

C

G701

G

G

G

E E

EE

E

E C

E

Ex2

Cx2

Ex2

TX-RX unit

E

706

704

D

B

705

GG

A

A

Fx2F

Fx3

Fx3

702

703

E

24

A : N09-2409-05B M7 : N10-2070-46C M3 x 8 : N67-3008-46D M2.6 x 6 : N80-2606-46E M2.6 x 6 (Br-Tap) : N87-2606-46F M2.6 x 20 (Br-Tap) : N87-2620-46G M3 x 8 (Br-Tap) BLK : N87-3008-45

Pats with the exploded numbers larger than 700 are not supplied.

TK-7150

33Pats with the exploded numbers larger than 700 are not supplied.

PACKINGC D

1

2

3

5 Instruction manual (B62-1619-00)

33 Item carton case (H52-1894-02)

46 Microphone (T91-0621-15)

4 Name plate (B11-1297-04)

9 DC cord assy (E30-3478-05)

37 Bracket (J29-0697-03)

43 Screw set (N99-2033-05)

35 Holder (J19-1584-05)

18 Fuse (Blade) (15A/32V) (F05-1537-05) x 3

14 Lead wire with connector (Short plug) (E37-1031-05)

20 Protective cover (F29-0478-05)

38 Band (J61-0307-05)

708Pamphlet x 2

709Packing fixture

711Packing fixture

710Protection bag

713Protection bag

712UPC code label

714Inner packing case

TK-7150

34

ADJUSTMENT

1. Key Functions

1-1. Front Panel

SCN SP OP OSA BMONCALL

Volume Display Selector Power switch

PF5PF1 PF2 PF4PF3 PF6

1-2. Panel Test Mode

When the Function is Off ( does not appear)

Controls Function

PF1 Test channel down

PF2 Test channel up

PF3 Test mode/Tuning mode changeover

PF4 Noise squelch off

PF5 Wide/Narrow changeover

When the narrow is on, appears

PF6 After pressing PF6 key, press PF3, PF4, PF5,

and PF6 to activate the following functions

(See the table below)

Selector knob Signalling up/down

When the Function is On ( appears)

Controls Function

PF1 No function

PF2 No function

PF3 appears on the right side

When the Sig No.9 (DTMF) is on, DTMF [9] is

transmitted.

When the Sig No.12 (MSK) is on, the

contineous MSK tone is transmitted.

PF4 Compander on (OP icon appears) / off

PF5 Beat shift on (B icon appears) / off

PF6 MSK speed changeover (1200/2400bps). When

MSK speed is 2400 bps, the Mail icon appears.

Selector knob Test signalling up/down

1-3. Panel Tuning mode

Controls Function

PF1 Tuning item down

PF2 Tuning item up

PF3 Test mode/Tuning mode changeover

PF4 Noise squelch off

PF5 Wide/Narrow changeover

PF6 Tuning value write→Move to the next tuning item

Selector knob Tuning value up/down

2. Panel Test ModeThe transceiver’s transmission output, receiver sensitiv-

ity, and other items are measured and QT, DQT, 2-Tone andDTMF signalling is decoded in this mode.

2-1. To Enter the Panel Test ModeHold down [PF1] and turn the power switch on to enter

this mode. The test frequency channel and test signallingchannel will be displayed.

Test frequency CH Test signalling CH

OP B

2-2. Test Frequency Channel (MHz)

CH RX TX

1/FC 155.15 155.00

2/FL 136.15 136.00

3/FH 173.85 174.00

4 145.55 145.50

5 164.55 164.50

6 155.00 155.00

7 155.20 155.20

8 155.40 155.40

2-3. Test Signalling Channel

No. Decode Encode

1 None None

2 LTR LTR

3 QT 67Hz QT 67Hz

4 QT 151.4Hz QT 151.4Hz

5 QT 210.7Hz QT 210.7Hz

6 QT 254.1Hz QT 254.1Hz

7 DQT 023N DQT 023N

8 DQT 754I DQT 754I

9 DTMF decode (159D) DTMF encode (159D)

10 2-Tone decode 2-Tone encode

A : 304.7Hz, B : 3106.0Hz A : 304.7Hz, B : 3106.0Hz

11 Single tone 979.9Hz Single tone 979.9Hz

12 MSK MSK

13 None Single tone : 1kHz

3. Panel Tuning ModeThe transceiver is adjusted in this mode.

3-1. To Enter the Panel Tuning ModePress the [PF3] key in the panel test mode.The adjustment items, the frequency and signalling, other

than the maximum deviation and sensitivity, return to the val-ues that were effective for the test frequency channel andtest signalling channel before entering the panel tuningmode.

TK-7150

35

3-2. Tuning Item and Display ( : 1~256)

Tuning item W/N LCD display S-LCD Signalling

Frequency – No signalling

Frequency low (2.5kHz) – No signalling

Frequency high (2.5kHz) – No signalling

TX high power (Low) – _ _ L No signalling

TX high power (Center) – _ _ C No signalling

TX high power (High) – _ _ H No signalling

TX low power (Low) – _ _ L No signalling

TX low power (Center) – _ _ C No signalling

TX low power (High) – _ _ H No signalling

Max. deviation (Low) Wide _ _ L No signalling

Max. deviation (Center) Wide _ _ C No signalling

Max. deviation (High) Wide _ _ H No signalling

Max. deviation (Low) Narrow n _ L No signalling

Max. deviation (Center) Narrow n _ C No signalling

Max. deviation (High) Narrow n _ H No signalling

DQT balance Wide Square waveform 100Hz

DQT balance Narrow n _ _ Square waveform 100Hz

QT deviation Wide QT : 67.0Hz

QT deviation Narrow n _ _ QT : 67.0Hz

DQT deviation Wide DQT : 023N

DQT deviation Narrow n _ _ DQT : 023N

LTR code deviation Wide LTR data : Area=0, Goto=12, Home=12, ID=47, Free=25

LTR code deviation Narrow n _ _ LTR data : Area=0, Goto=12, Home=12, ID=47, Free=25

DTMF deviation Wide DTMF : 9

DTMF deviation Narrow n _ _ DTMF : 9

MSK deviation Wide 0xAAA···

MSK deviation Narrow n _ _ 0xAAA···

Single tone deviation Wide 1000Hz

Single tone deviation Narrow n _ _ 1000Hz

Sensitivity – _ _ L No signalling, Squelch off

Sensitivity – _ C L No signalling, Squelch off

Sensitivity – _ _ C No signalling, Squelch off

Sensitivity – _ H C No signalling, Squelch off

Sensitivity – _ _ H No signalling, Squelch off

Squelch tight Wide No signalling

Squelch tight Narrow n _ _ No signalling

Squelch open Wide No signalling

Squelch open Narrow n _ _ No signalling

F r e q _ _ _ _ _

F r e q _ L O _ _

F r e q _ H I _ _

H i _ P o w e r _

H i _ P o w e r _

H i _ P o w e r _

L o _ P o w e r _

L o _ P o w e r _

L o _ P o w e r _

M a x _ D e v _ _

M a x _ D e v _ _

M a x _ D e v _ _

M a x _ D e v _ _

M a x _ D e v _ _

M a x _ D e v _ _

D Q T _ B a l _ _

D Q T _ B a l _ _

Q T _ D e v _ _ _

Q T _ D e v _ _ _

D Q T _ D e v _ _

D Q T _ D e v _ _

L T R _ D e v _ _

L T R _ D e v _ _

D T M F _ D e v _

D T M F _ D e v _

M S K _ D e v _ _

M S K _ D e v _ _

T o n e _ D e v _

T o n e _ D e v _

S e n s _ _ _ _ _

S e n s _ _ _ _ _

S e n s _ _ _ _ _

S e n s _ _ _ _ _

S e n s _ _ _ _ _

S q l _ T _ _ _ _

S q l _ T _ _ _ _

S q l _ O _ _ _ _

S q l _ O _ _ _ _

ADJUSTMENT

TK-7150

36

3-3. Flow Chart1. : Use the [PF1] and [PF2] keys.2. : Use the [PF6] key.3. Use the [SELECTOR] knob to set an adjustment value (1

to 256) for each adjustment item.4. Use the [PF6] key to move to the next item.

[PF1]+Power ON

Panel test mode[PF3]

Frequency

TX high power

Frequency low (2.5kHz)

Frequency high (2.5kHz)

TX low power

Max. deviation

DQT balance

TX high power (Low)

[PF2][PF1] [PF6]

[PF6]

[PF6]

TX high power (Center)

TX high power (High)

TX low power (Low)

TX low power (Center)

TX low power (High)

Max. deviation (Low)

Max. deviation (Center)

Max. deviation (High)

Sensitivity (Low)

Sensitivity (HC)

Sensitivity (Center)

Sensitivity (CL)

Sensitivity (High)

QT deviation

DQT deviation

LTR code deviation

DTMF deviation

MSK deviation

Single tone deviation

Squelch tight

Squelch open

Sensitivity

ADJUSTMENT

TK-7150

37

4. Test Equipment Required for Alignment

Test Equipment Major Specifications

1. Standard Signal Generator Frequency Range 136 to 174MHz

(SSG) Modulation Frequency modulation and external modulation

Output 0.1µV to greater than 1mV

2. Power Meter Input Impedance 50Ω

Operation Frequency 136 to 174MHz or more

Measurement Capability Vicinity of 50W

3. Deviation Meter Frequency Range 136 to 174MHz

4. Digital Volt Meter Measuring Range 1 to 20V DC

(DVM) Accuracy High input impedance for minimum circuit loading

5. Oscilloscope DC through 30MHz

6. High Sensitivity Frequency Range 10Hz to 600MHz

Frequency Counter Frequency Stability 0.2ppm or less

7. Ammeter 13A or more

8. AF Volt Meter Frequency Range 50Hz to 10kHz

(AF VTVM) Voltage Range 3mV to 3V

9. Audio Generator (AG) Frequency Range 50Hz to 5kHz

Output 0 to 1V

10. Distortion Meter Capability 3% or less at 1kHz

Input Level 50mV to 10Vrms

11. Voltmeter Measuring Range 10 to 1.5V DC or less

Input Impedance 50kΩ/V or greater

12. 4Ω Dummy Load Approx. 4Ω, 20W

13. Regulated Power Supply 13.6V, approx. 20A (adjustable from 9 to 20V)

Useful if ammeter requipped

4-3. Test Cable for Microphone inputThe following test cable are recommended.

4-1. Test Cable for Speaker Output

1

36

5

4

Crimp terminal(E23-0613-05)

SP OUTSP OUT

DUMMY

4Ω/2

0W

SP220µF 16WV

SPToAF VTVMDistortionmeter

+

+

1

8

Cut

HOOK(BRN)

MIC (WHT)MICG

ToAGAF VTVM

PTT(YEL)

PTT(RED)

PTT SW

Plug cordPart No. E30-3360-08

8 pin

8 pin

1 : NC2 : +B3 : GND4 : PTT/TXD1 (PC serial data from radio)

MIC connector (Front panel view)

5 : MIC GND6 : MIC7 : HOOK/RXD1 (PC serial data to radio)8 : NC

ADJUSTMENT

4-2. Repair Jig (Chassis)To check the voltage on the foil side of the TX-RX unit or to

adjust the PLL lock voltage, use the Repair jig (Part No. A10-4065-02).

TK-7150

38

ADJUSTMENT

5. Warnings When Removing or Installing

the Shielding Cover1. When handling with the shielding cover, do not damage

the components on the TX-RX unit.2. When installing the shielding cover, insert the cover from

the rear side.3. When removing the shielding cover, squeeze the hole

marked with an arrow as shown on the diagram and pull itstraight up.

Packing

• Adjustment frequency (MHz)

CH RX TX1/FC 155.15 155.002/FL 136.15 136.003/FH 173.85 174.00

4 145.55 145.505 164.55 164.506 155.00 155.007 155.20 155.208 155.40 155.40

• Signalling

No. Decode Encode1 None None2 LTR LTR3 QT 67Hz QT 67Hz4 QT 151.4Hz QT 151.4Hz5 QT 210.7Hz QT 210.7Hz6 QT 254.1Hz QT 254.1Hz7 DQT 023N DQT 023N8 DQT 754I DQT 754I9 DTMF decode (159D) DTMF encode (159D)10 2-Tone decode 2-Tone encode

A : 304.7Hz, B : 3106.0Hz A : 304.7Hz, B : 3106.0Hz11 Single tone 979.9Hz Single tone 979.9Hz12 MSK MSK13 None Single tone : 1kHz

1. Frequency • Frequency range (MHz)list K : 136~174

2. Setting • Receiver section • Transmitter sectionThe indicated SSG output level are for maximum output.Whenever there is no modulation desingnation,standard modulation (MOD : 1kHz, DEV : 3kHz (Wide),DEV : 1.5kHz (Narrow)) is indicated.

When adjusting the PLL lock voltage, you must set If you transmit without connecting a 50Ω terminator on thethe TX POWER value to 0. antenna connector, the FET final transistor may be damaged.

4Ω dummy load

AF VTVM

Oscilloscope

Distortion meter

SSG

ACC (SP)

ANT

AG AF VTVM

MIC

PTT

Power meter

Coupler

Deviationmeter

Frequencycounter

ANT

– +– +

+–

AmmeterPower supply

DC IN

Item Condition

Measurement Adjustment

Specifications/RemarksTest-equipment Unit Terminal PartsUnit Method

6. Common Section

TK-7150

39

Item Condition



ADJUSTMENT

3. PLL lock 1) CH-SIG : 3-1 DC VM TX-RX CV TX-RX TC502 8.2V ±0.1Vvoltage Power meter

2) CH-SIG : 3-1 TC501PTT : ON

3) CH-SIG : 2-1 Check 1.8V or more

4) CH-SIG : 2-1 2.0V or morePTT : ON

4. Transmit 1) CH-SIG : 1-1 Power meter Rear ANT Front Selector CH-1 frequency ±50Hzfrequency Select Freq_ _ _ _ _ f. counter panel panel knob

in tuning modePTT : ON

5. Transmit 1) Select Freq_LO_ _ 136.00250MHz ±50Hzfrequency Frequency : 136.00250MHz(tune) PTT : ON

2) Select Freq_HI_ _ 173.99750MHz ±50HzFrequency : 173.99750MHzPTT : ON

6. MCF 1) CH-SIG : 1-1 Spectrum TX-RX CN201 TX-RX L205 Adjust it to make gain maximum, and make the• Wide Spectrum analyzer analyzer L207 band flat as ahown in the below.

Span : 25kHz L209Scale : 2dB div Tracking CN202Center frequency : 44.850MHz generator

Tracking generatorOutput : –30dBm

• Narrow 1) [PF5] key : Set the narrow L206 Adjust it to make gain maximum, and make the“n_ _” appear on the LCD L208 band flat as ahown in the below.

L210

7. AF coil 1) CH-SIG : 1-1 SSG TX-RX CN201 TX-RX L201 Maximum audioadjustment SSG output : –-20dBm (FM) output level.

frequency : 44.85MHz AF VTVM Rear EXT.SP DEV : 1.5kHz 4Ω dummy panel MOD : 1kHz loadSSG signal inject to CN201.

REF –30.0dBm2dB/

MARKER 4.50kHz –0.28dB

RBW 300HzVBW 300HzDL –22.02dBmSWP 1.3s

SPAN 25.0kHz CENTER 44.8500MHz

ATT 10dB

3dB or more (±10kHz)

–4.5kHz +4.5kHz

–10kHz +10kHz

1.5dB max.

REF –30.0dBm2dB/

MARKER 3.00kHz –0.42dB

RBW 300HzVBW 300HzDL –22.02dBmSWP 1.0s

SPAN 20.0kHz CENTER 44.8500MHz

ATT 10dB

3dB or more (±7kHz)

–7kHz

–3kHz

+7kHz

+3kHz

1.5dB max.

TK-7150

40

Item Condition



ADJUSTMENT

8. TX high 1) CH-SIG : 3-1 Power meter Rear ANT TX-RX VR1 53W 53.0W±0.5Wpower Select _ _H Ammeter panel

Hi_Power_

in tuning modePTT : ONKeep data at 256

2) CH-SIG : 2-1 Front Selector 50W 50.0W±1WSelect _ _L panel knob 11A or less

Hi_Powe_


3) CH-SIG : 1-1Select _ _C

Hi_Powe_


4) CH-SIG : 3-1Select _ _H

Hi_Powe_


9. TX low 1) CH-SIG : 2-1 15W 15W±1Wpower Select _ _L 11A or less

Lo_Power_



Lo_Power_



Lo_Power_


10. Maximum 1) CH-SIG : 2-1 Power meter Rear ANT Front Selector ±3.8kHz ±0.1kHzdeviation Select _ _L Deviation panel panel knob• Wide Max_Dev_ _ meter

in tuning modePTT : ON AF VTVM Front MICDeviation meter filter AG panel

HPF : OFF OscilloscopeLPF : 15kHzDe-emphasis : OFF

AG : 1kHz/50mV2) CH-SIG : 1-1

Select _ _CMax_Dev_ _



Max_Dev_ _


TK-7150

41

Item Condition



ADJUSTMENT

• Narrow 4) CH-SIG : 2-1 Power meter Rear ANT Front Selector ±1.75kHz ±0.05kHz[PF5] key : Set the narrow Deviation panel panel knob

n_L meterMax_Dev_ _

in tuning mode AF VTVM Front MICPTT : ON AG panel

Oscilloscope5) CH-SIG : 1-1

Select n_CMax_Dev_ _


6) CH-SIG : 3-1Select n_H

Max_Dev_ _


11. MIC 1) CH-SIG : 1-1 TX-RX VR700 Check 2.2~3.7kHzseisitivity PTT : ON(Wide only) Deviation meter filter

HPF : OFFLPF : 15kHzDe-emphasis : OFF

AG : 1kHz/5mV

12. DQT 1) CH-SIG : 1-1 Front Selector Wide/Narrow Flat the A parts.balance Select DQT_Bal_ _ panel knob Make the• Wide in tuning mode demodulation wave-

PTT : ON form neat.Deviation meter filter


• Narrow 2) [PF5] key : Set the narrown_ _DQT_Bal_ _


13. QT 1) CH-SIG : 1-3 ±0.75kHz ±0.05kHzdeviation Select QT_Dev_ _ _

• Wide in tuning modePTT : ONDeviation meter filter


• Narrow 2) [PF5] key : Set the narrow ±0.35kHz ±0.05kHzn_ _QT_Dev_ _ _


A

A

TK-7150

42

Item Condition



ADJUSTMENT

14. DQT 1) CH-SIG : 1-7 Power meter Rear ANT Front Selector ±0.75kHz ±0.05kHzdeviation Select DQT_Dev_ _ Deviation panel panel knob• Wide in tuning mode meter

PTT : ONDeviation meter filter AF VTVM Front MIC

HPF : OFF AG panelLPF : 3kHz OscilloscopeDe-emphasis : OFF

• Narrow 2) [PF5] key : Set the narrow ±0.35kHz ±0.05kHzn_ _DQT_Dev_ _


15. LTR code 1) CH-SIG : 1-2 1.00kHz ±0.05kHzdeviation Select LTR_Dev_ _



• Narrow 2) [PF5] key : Set the narrow 0.75kHz ±0.05kHzn_ _LTR_Dev_ _


16. DTMF 1) CH-SIG : 1-9 ±3.0kHz ±0.1kHzdeviation Select DTMF_Dev_



• Narrow 2) [PF5] key : Set the narrow ±1.5kHz ±0.1kHzn_ _DTMF_Dev_


17. MSK 1) CH-SIG : 1-12 ±3.0kHz ±0.1kHzdeviation Select MSK_Dev_ _



• Narrow 2) [PF5] key : Set the narrow ±1.5kHz ±0.05kHzn_ _MSK_Dev_ _


TK-7150

43

Item Condition



ADJUSTMENT

18. Single tone 1) CH-SIG : 1-11 Power meter Rear ANT Front Selector ±3.0kHz ±0.1kHzdeviation Select Tone_Dev_ Deviation panel panel knob• Wide in tuning mode meter

PTT : ONDeviation meter filter AF VTVM Front MIC

HPF : OFF AG panelLPF : 15kHz OscilloscopeDe-emphasis : OFF

• Narrow 2) [PF5] key : Set the narrow ±1.5kHz ±0.05kHzn_ _Tone_Dev_


19. Sensitivity 1) CH-SIG : 2-1 SSG Rear ANT Front Selector Adjust for maximum SINAD 12dB or moreSelect _ _L panel panel knob SINAD.

Sens_ _ _ _ _

in tuning mode AF VTVM EXT.SPSSG output : –117dBm/0.32µV DistortionAF output : 2V/4Ω meter

Oscilloscope2) CH-SIG : 4-1 4Ω dummy

Select _CL loadSens_ _ _ _ _

in tuning mode


Sens_ _ _ _ _

in tuning mode

4) CH-SIG : 5-1Select _HC

Sens_ _ _ _ _

in tuning mode


Sens_ _ _ _ _

in tuning mode

20. Squelch 1) CH-SIG : 1-1 Adjust to point of Set the value to 255.tight Select Sql_T_ _ _ _ opening squelch Adjust the SSG output to• Wide in tuning mode “Condition”.

SSG output : Value when 6dB Then, decrease the value tois added from the sensitivity the point of opening thevalue of 12dB SINAD. squelch.

• Narrow 2) [PF5] key : Set the narrown_ _Sql_T_ _ _ _

in tuning mode

TK-7150

44

CN201

CN202

VR700

VR1

L201

1 2 L205

L206CV

L207

L208

L209

L210

12

TC501TX

TC502RX

CV

7. Adjustment Points

7-1. Component Side View 7-2. Foil Side View

VR1 : TX high power (High)VR700 : MIC seisitivity

TC501 : PLL lock voltage (TX)TC502 : PLL lock voltage (RX)

L201 : AF coil adjustmentL205,207,209 : MCF (Wide)L206,208,210 : MCF (Narrow)

Item Condition

Measurement AdjustmentSpecifications/

RemarksTest-equipment Unit Terminal PartsUnit Method

ADJUSTMENT

21. Squelch 1) CH-SIG : 1-1 SSG Rear ANT Front Selector Adjust to point of Set the value to 255.open Select Sql_O_ _ _ _ panel panel knob opening squelch Adjust the SSG out-• Wide in tuning mode put to “Condition”.

SSG output : Value when 3dB AF VTVM EXT.SP Then, decrease theis subtracted from the Distortion value to the point ofsensitivity value of 12dB meter opening the squelch.SINAD. Oscilloscope

4Ω dummy• Narrow 2) [PF5] key : Set the narrow load

n_ _Sql_O_ _ _ _

in tuning modeSSG output : Value when 4dB

is subtracted from thesensitivity value of 12dBSINAD.

• Wide/Narrow 3) SSG output : OFF Check Squelch must beclosed.

Note : When you change the Squelch adjustment value, connect all necessary measuring equipment (as stated in the adjustment procedure), thenadjust it to the SSG output value.

A B C D E F G H I J K L M N O P Q R S

1

2

3

4

5

6

7

8

9

10

11

12

13

14

Q90

1GS

D

Q903

E

B

C

Q904

Q908

Q909

Q91

0

Q91

1

L901

L902

R90

2

R90

4

1M

E

MIC

E RES

ET

TXD

RX

D

E PSW

SB

IRS

ES2

11

R90

5

R90

6

R907

R913

R914

R91

5

R91

6

R91

7

R91

8

R919

CN

901

CN902

R92

0

1E

VC

CC

EC

L DI

DO

DIS

PL

ED

AL

ED

KN

C10

CN905

CN906

R922

R92

3

R924

R92

5R926

R927R

928 R931

R932R

933 R934

R93

5

R93

6

R93

7

R93

8 R93

9

C90

1

C902

C903

R94

0

E P4 P3 P2 P1

1 5

C90

4

C905

R942

C906

R94

3

C907

R944

C909

R94

5R

946

R94

7

R94

8

R949

C91

0

C91

1

C91

2

C914

R950

C91

5

C91

6

C91

7

C91

8

R95

6

R95

7

R95

8

R95

9

C92

1

C924

R960

C925

TP1

TP2

C928

C92

9

C93

0

C93

9

C941C942

C943

C944

D902

D90

3

D904

D905

D906

D90

7

D916

D917

D918

IC901

O

I

GE

BLC

DM

MIC

PTT

SB

HK

ME

1

5

2

1

5

3

6

4

J72-0840-19 A/2

B/2

+

+

2

1

ES2

IRS

+

J901

P1 5

Q902G

DS

Q905

Q906

Q907

R90

8

R909R910

R94

1

X901

R95

1

R95

2

R95

3R

954

R95

5

C91

9

C922

C923

S1

VR901VOL

C92

6C

927

C931 C93

2

C93

3

C93

4C

935

C93

8

W1

D90

8

D90

9

D91

0

D91

1

D912

D91

3

D91

4

D915

IC90

2 G OI

IC904

E

BLC

DM 15

84

MIC

PTT

SB

HK

ME

PF1 PF2 PF3 PF4 PF5 PF6

POWER

1

2526 50

51

7576100

E

P4

P3

P2

1

J72-0840-19 A/2

B/21

5

23

6

4

DISPLAY UNIT (X54-3400-10) Component side view (J72-0840-19)

DISPLAY UNIT (X54-3400-10) Foil side view (J72-0840-19)

Component side

Foil side

Layer 1Layer 2Layer 3Layer 4

Component side

Foil side


TK-7150 PC BOARD

45 46

Ref. No. Address

IC902 3F

IC904 3I

Q902 3G

Q905 2I

Ref. No. Address

Q906 4J

Q907 4J

D908 5D

D909 5F

Ref. No. Address

D910 5H

D911 5J

D912 4M

D913 5K

Ref. No. Address

D914 5M

D915 4N

Ref. No. Address

IC901 9F

Q901 10C

Q903 9H

Q904 10F

Ref. No. Address

Q908 10J

Q909 10B

Q910 10H

Q911 11G

Ref. No. Address

D902 9C

D903 10D

D904 10E

D905 9B

Ref. No. Address

D906 10C

D907 9I

D916 9C

D917 11B

Ref. No. Address

D918 10A

SRQPONMLKJIHGFEDCBA

1

2

3

4

5

6

7

8

9

10

11

12

13

14

Q90

1GS

D

Q903

E

B

C

Q904

Q908

Q909

Q91

0

Q91

1

L901

L902

R90

2

R90

4

1M

E

MIC E

RES

ET

TXD

RX

D E

PSW SB

IRS

ES2

11

R90

5

R90

6

R907

R913

R914

R91

5

R91

6

R91

7

R91

8

R919

CN

901

CN902

R92

01

E VC

CC

EC

LD

ID

OD

ISP

LE

DA

LE

DK

NC

10

CN905

CN906

R922

R92

3R924

R92

5

R926

R927

R92

8

R931

R932

R93

3 R934

R93

5

R93

6

R93

7

R93

8

R93

9

C90

1

C902

C903

R94

0

E P4 P3 P1 P1

1 5

C90

4

C905

R942

C906

R94

3

C907

R944

C909

R94

5R

946

R94

7

R94

8

R949

C91

0

C91

1

C91

2C914

R950

C91

5

C91

6 C91

7

C91

8

R95

6

R95

7

R95

8

R95

9

C92

1

C924

R960

C925

TP1

TP2

C928

C92

9

C93

0

C93

9

C941C942

C943

C944

D902

D90

3 D904

D905

D906

D90

7

D916

D917

D918

IC901

O

I

G

+

+

2

1

ES2

IRS

+

J901

E

Q902G

DS

Q905

Q906

Q907

R90

8

R909R910

R94

1

X901

R95

1

R95

2

R95

3R

954

R95

5

C91

9

C922

C923

S1

VR901VOL

C92

6C

927

C931 C93

2

C93

3

C93

4

C93

5C

938

W1

D90

8

D90

9

D91

0

D91

1

D912

D91

3

D91

4

D915

IC90

2 G OI

IC904

E

BLC

DM 15

84

MIC

PTT

SB

HK

ME

PF1 PF2 PF3 PF4 PF5 PF6

POWER

1

2526 50

51

7576100

P1

P2

P3

P4

5

1

J72-0840-19 A/2

B/21

5

23

6

4

PC BOARD TK-7150

47 48

DISPLAY UNIT (X54-3400-10) Component side view + Foil side (J72-0840-19)

Component side

Foil side


Connect 1 and 4

Ref. No. Address

IC901 5F

IC902 3F

IC904 4H

Q901 5C

Q902 3G

Q903 5H

Q904 5F

Q905 2I

Ref. No. Address

Q906 4J

Q907 4J

Q908 5I

Q909 4B

Q910 4H

Q911 3G

D902 5C

D903 4D

Ref. No. Address

D904 4D

D905 6B

D906 4B

D907 5I

D908 6D

D909 6F

D910 6G

D911 6I

Ref. No. Address

D912 5M

D913 6K

D914 6M

D915 5N

D916 5C

D917 4B

D918 5A


1

2

3

4

5

6

7

8

9

10

11

12

13

14

C20

C21

C22

C23

CP71

0

R210

C24

C25

XF201(WIDE)

CP71

1

R211

XF202(NARROW)

CP71

2

R212

C27

CP713

R213

R271

R288

TH20

2

CP714

R214

CP7151

100

C29

R217

C30

C31

+

CN201

CN20

2

C33

CN203

C34

R221

C35

C36

C37

C38

R801

C39

R227

R805

R806

R807

C40

R808

R866

R867

R868

C42 C43

C44

C46

C47

R233

C48

R810

R813

R853

C50

R819

C201

C53

C205 TH201C206

R820

C208

C209

R246

R823 R859

R825

R8276

1

IGN

OS2

OS1

ES2

ES1

IRS

C211

X201

C62

C213

D790

D79

1

R253

R254 R255

R831

R256

R257 R258

R259

R837

F100

R260

C800

C74

R261

C75

C65

R262

C802

C226

R263

C803

C844

C77

C804

R264

R265

R841

R266

R267

C807

R843

R268

R269

C809

R845

R846

K700

C80

C233

C234

R270R272

C812

17

16

R273

R274

R850

R276

C819

R857

C92

C93

C243

C94

C244

C820

R861R862

C831

C257

D1

D3

Q103

S

G

D

D4

Q104

Q105

Q10

6

Q10

7

BE CBE C

D7

C263

D20

3

D204

NARROW

WIDE

D207

C267

D208

C268

D209

C269

C846

C270

C271

Q501

C272

C273

Q503

C274

Q504

Q50

5

C276

Q50

6

C277

C278

C279

Q70

0GS

D

Q70

2

C280

C281

IC201

1

8 9

16

C282

C283

C284

C285

L501

C286

Q516

C287

L503

C288

Q518

C289

Q51

9

L506

Q71

0

L509

Q71

3

C290

L700

Q520

C291

L701

Q521

Q716

C292

C293

L703

C294

C295

Q719

L706

L513

L707

L708

L709

Q720

TH1

TH2

L710

L711

L712

L520

R106

R107

R108

R109R1

10R1

11

CF201 (D)

CF202 (F)

CF203 (D)

CF204 (F)

R501

R502

R503

R504

R505

R506

CN102+B

R507

R508

R509

R122

L4

R700

L5

R701

L6

R702

R126

L7

R703

L8

C89

C90

R510

R704

L9

R511

R705

R512

R706

R513

R707

R708

R515R709

R516

R517

R518 R519R710

R711

R713

L10

L11

R521

R715

L12

L13

R523

L14

R718

C101

R527

R528

CN700

R529

CN703

CN704

R726

R727

R728

C110

C305

R729

C114

C116

R730

C118

R731

C501

C119

C502

C503

C504

C505

C506

C507

C120

C509

C121

C123

C700

R15

C701

C125

C702

C126

C703

C704

C128

C510

X501

C705

C512

C513

C707

C514

C708

C709

C516

R553

R554

C130

R21

C519

C131

R749

R22

C132

R557

C133

R558

C710

X700

C711

CN73

1

C712

CN732

C713

CN733

C520

C714

CN734

C521

C715

R752

C523

C717

R753

C524

C718

R754

C525

R755R7

56

R563

R757

C528

R564

R758

C529

R759

R566

R33

R567

R34

R568

R569

C530

R760

VR70

0

C531

R761

R762

C534

R570

C535

R765

C729

R571

R572

R573

C538

C730

VR1

8T

C731

C732

C733

C734

R771

C735

C542

C736

CN75

6

R773

C737

C738

R775

R778

R50

D101

R52

C740

R54

Q20

1

R55

C742

Q20

2

Q203

C744

Q20

5

R59

C746

R784

C748

Q20

9

G

GD

D

SG

DS

SG

D S

C749

R787

2 1

R788

BUSY

EMG

KEY

AU

XIN

HST

ON

TCN

TD

ATA E 8C

PTO

DET

O NC

NC

1 14

R789

Q21

0

Q21

1

Q21

2

Q21

3BCE

C560

C561

L201

L203

1 2

L205

L206

L207

L208

R798

L209

D509C5

69

C760

IC10

4O

GI

D70

1

IC105

I

O

G

IC107 OIG

OIG

D70

3

L210

D510

D704

TP1

IC108

D70

5

D51

3

C573

D70

7

D51

4

D70

8

L215

1

2

C575

D70

9

D51

5

ME

MIC E

RESE

T

TXD

RXD E

PSW SB IRS

ES2

1 11L218

C578

L219

D71

0

D71

4

D71

5

L221

IC501

1

8 9

16

L222

L223

C777

L224

C584

L225

C585C586

C587

IC701

IC702

IC70

3

IC70

4

1 458

IC705

IC706C593

IC707

C594

IC708

IC709145

8

145

8

C793IC716

C796

C799

CP700

IC72

0

1

189 16

2

R200

CP701

IC721

CP702

R202

CP703

CP70

4

IC72

4

C19

CP70

5CP

706

R206

CP70

7

CP70

8

R208

CP70

9

+

+

+

+

+ +

+

+

RXD3

2526

5051

1

16 17

32

7576

G SD

1

1

1 458

4

4

5

5

8 1

8

8 9

161

12 13

24

+

+

+ +

+

+

+

+

+

+

EP

CP

9C

MB

5C

EP DT CPUL

STR

8CL

8C

RSSIPDET

TEMP2TEMP1

CDET8RC ASQ

8TC

MB

3.3V

GND

GND

5C

1

3 4

5

8R

5C9C

W/N

+

+

+

+

+

CV

5C

8R12CL

Q4G

S

S

D

+

Q5G

S

S

D

J72-0839-19

25 14

113

TX-RX UNIT (X57-6570-10) Component side view (J72-0839-19)

TK-7150 PC BOARD

49 50

Ref. No. Address

IC104 4A

IC105 4C

IC107 5D

IC108 6D

IC201 8I

IC501 11J

IC701 11C

IC702 9D

IC703 8B

IC704 12D

IC705 13C

IC706 11E

IC707 10E

IC708 12E

IC709 12E

IC716 10E

IC720 6B

IC721 8E

IC724 11F

Q4 5H

Q5 5L

Q103 4D

Q104 6E

Q105 5E

Q106 6E

Q107 5E

Q201 8K

Q202 8K

Q203 9I

Q205 8J

Q209 11O

Q210 11O

Q211 12O

Q212 12O

Q213 9Q

Q501 10I

Q503 10I

Q504 10I

Q505 12G

Q506 12G

Ref. No. Address

Q516 11K

Q518 12K

Q519 12K

Q520 11I

Q521 12K

Q700 9C

Q702 12D

Q710 7D

Q713 12D

Q716 3E

Q719 9B

Q720 9A

D1 3J

D3 6Q

D4 7Q

D7 6G

D101 3F

D203 8F

D204 8H

D207 12Q

D208 10Q

D209 8Q

D509 11G

D510 11G

D513 10K

D514 10K

D515 12J

D701 3E

D703 3C

D704 10D

D705 3B

D707 3C

D708 3C

D709 3B

D710 2D

D714 5E

D715 3D

D790 10E

D791 13K

Component side

Foil side

Layer 1Layer 2Layer 3Layer 4Layer 5Layer 6

SRQPONMLKJIHGFEDCBA

1

2

3

4

5

6

7

8

9

10

11

12

13

14

J700

C26

R215

R216

R218

R219

C32

R220

R222

R223

R800

R224

R225

R802R2

26

R803

R228

R804

R229

R230

C45

R231

R232

R234

R235

C49

R811

R236

R812

R237R238 R814

R239

R815R816

R817

C200

R818

C51

C202

C203

R240

C204

C54

R241

R242

R243

C207

R244

R245

R821

D785

R822

D786

R247

D78

7

R248

R824

D78

8

R249

D78

9

R826

R828

C210R829

C212

C63

R250

C214

R251

C215

R252

C216

C217

C67

D79

3

NC RXD2 TXD2 AO3 DI MI2 E AO2 TXD3 RXD3 E AI4 AI2

MEAI3HR2AO4AI1AO1DEOEAFOHR1TXSSB

C218

C219

R832

R834

R835

R836

R838

C220

R839

C221C222C223

C224

C801

C225

C227

C228

C229

R842

C806

C808

R844

R847

C230 R848

C231

R849

C232

C810

C235

C811

C236

C237

C813

C238

C814

R851

C239

C815

R852

+

+

+

+

+

C816

R853

C817

R854

C240

C241

C242

C245

C246

C822

C247

C823

C248

R284

C249

C1

C825R285

C2

C826

R286

C3

C827

R287

R863

C4

C828

R864

C5

C829

R289

+

+

+R865

C6 C7 C8

C251

C9

C252

C253

C254

C830

C255

C256

C832

C833

C258

C834

C259

Q101

C835

C805

D2

Q102

C836

C837 C838

D5

D6

C260

Q108

C261

Q10

9

D20

1

C262

D20

2

C264

D205

C265

D206

C266

Q11

0

Q11

1C8

45

Q112Q113

Q502

Q50

7

Q508

Q50

9G

DSG

DS

Q70

1

Q70

3

Q51

0

Q70

4

Q511

Q70

5

Q512

8C

8R

Q70

6

IC202

Q51

3

Q707

Q514

Q708

Q515

Q709

Q51

7

L504

L505

L507

L508

Q711

Q71

2G S

D

Q71

4

L510

L704

L511

L705

L5129C

L514

L515

L516

L517

L519

R101

R102

R103

R104 R105

D11

R112

R113 R114R115

R116

R117

R118

R119

R120

R121

L2 L3

R123

R124

R125

R514R520R522

R524

L15

R525

C102

R526L1

6

C103

L17

C104

CN701

C105

C106

C107

C108

C109

R530

R531

R532 R533R534

IC11

4 5

8

R535

C111

IC21

4 5

8

R536

C112

C306

R537

C113

R538R539

C115

C117

R540 R541

R542

R543

R10

R544

C508

R11

R12

R546

C122

R13

R547

R14

R548

C124

R549STR

R16

R17

C127

R18

R19

C129

C706

R550

C515

R551

C517

R20

R555

TC50

1TX

R556

TC50

2RX

R23

R24

C134

Q1

R559

C135

R26

Q2B

C

E

R27

R28

R29

R751

CN73

5

C522

C716

CN736CN737

R560 8CL

8C

CN738

R561

C719

CN739

R562

C526 CV8CL

C527

R31

R565

R32

C720

CN74

0

R1

C721

CN741

R2

R36

C722

CN742

R37

C723

CN743

R38

R4

C724

CN744

R5

R39

C725

CN745

R6

C532

C726

CN74

6

R7

C533

C727

R763

CN74

7

C728 R764

CN748

R9

CN749

R766

C537

R767

R40

R768

R41

C539

R769

R42

R43

R44

CN75

0

R45

CN751

R46

CN752

R47

CN75

3

C540

R770

R48

CN75

4

C541

R49

CN755

R772

C543

C544

R774

C545

C739

C546

R776

C547

R777

C548

C549 R779

R51

D10

2

D103

R53

D104

D105

C741

D10

6

R56

C743

R58

C550

D10

8

R780

Q204

C551

R781

C745

D10

9

C552

R782

Q20

6

Q20

7

B C E

C553

C747

R783

Q20

8BCE

C554

C555

R785

C556

R786

C557

C559

C750C751

C752

C753

C754

D50

1

C755

C562

D50

2

C756

L202

D50

3

C563

C757

R793

1 14E8C

PTO

RXONC

NC

BC4

BC3

BC2

BC1

AC

RXI

TXO

TXI

C564

D50

4

C758

R794

L204

D505

C565

C759

R795D506

C567

D507

R797

C568

D508

R799

IC10

1

IC10

2

178

1 345

13 4

5

1 345

14IC

103

D70

0

C761

IC10

6

C762

D70

2

C570

C764

L211C5

71

D51

1C765

L212

D51

2

C572

C766

D70

6

L213

C767

L214

C574

C768

C769

L216

C576

L217

C577

C579

C770

C771

D71

1

D71

2C7

72

C773

C580

L220 C774

C581

C775

C776

C778

L713

C780

C779

IC70

0

189 16

C781

C782

C784

C787

C788

C789

IC710

C790

IC71

11 3

45

IC713

C794

IC71

4

C795

C785

IC717

C797

IC718C798

IC719

C10

C11

C12

C13

C14

C15

C16

IC7221

1

4 5

8

IC7151

1

1

8 9

16

1213

244 5

8

IC7121

4 5

8

1 458

1

89

16

3 4

5

IC72

51 3

45

C17

R203

IC72

3

O G

GIOI

C18

R204

R205

R207

R209

2514

1 13

++

+

1144

3637

7273 108

109

+

+

+

++

+

+

+

+

++

+

++

GS

D

+

MO

+

+

J72-0839-19

ME

MICE

RESE

T

TXD

RXDE

PSWSBIRS

ES2

TX-RX UNIT (X57-6570-10) Foil side view (J72-0839-19)

51 52

PC BOARD TK-7150

Ref. No. Address

IC1 4M

IC2 6G

IC101 6O

IC102 5P

IC103 6P

IC106 8P

IC202 9K

IC700 12O

IC710 11Q

IC711 13R

IC712 11O

IC713 10O

IC714 11N

IC715 9O

IC717 9R

IC718 9P

IC719 8O

IC722 8Q

IC723 7O

IC725 13O

Q1 6K

Q2 6M

Q101 4O

Q102 4P

Q108 4P

Q109 5O

Q110 5P

Q111 4P

Q112 4Q

Q113 4Q

Q204 9J

Q206 8I

Q207 9D

Q208 11G

Q502 12M

Q507 11J

Q508 11M

Q509 10J

Q510 10J

Q511 10M

Q512 11I

Q513 10J

Q514 10I

Q515 10I

Q517 12G

Q701 3R

Ref. No. Address

Q703 3P

Q704 3Q

Q705 3P

Q706 3Q

Q707 12N

Q708 12O

Q709 10P

Q711 9Q

Q712 6Q

Q714 6Q

D2 6H

D5 4B

D6 3B

D11 6F

D102 4P

D103 4P

D104 4P

D105 4P

D106 4O

D108 5P

D109 5Q

D201 9I

D202 9I

D205 9H

D206 9E

D501 11L

D502 10L

D503 11L

D504 10L

D505 11L

D506 11L

D507 10L

D508 10L

D511 11K

D512 11M

D700 4Q

D702 3O

D706 3R

D711 11N

D712 11O

D785 13J

D786 13J

D787 9R

D788 9R

D789 10N

D793 3O

Component side

Foil side



1

2

3

4

5

6

7

8

9

10

11

12

13

14

J700

C26

R215

R216

R218

R219

C32

R220

R222

R223

R800

R224

R225

R802

R226

R803

R228

R804

R229

R230

C45

R231

R232

R234

R235

C49

R811

R236

R812

R237 R238R814

R239

R815R816

R817

C200

R818

C51

C202

C203

R240

C204

C54

R241

R242

R243

C207

R244

R245

R821

D785

R822

D786

R247

D78

7

R248

R824

D78

8

R249

D78

9

R826

R828

C210R829

C212

C63

R250

C214

R251

C215

R252

C216C2

17

C67

D79

3

NCRXD2TXD2AO3DIMI2EAO2TXD3RXD3EAI4AI2

ME AI3 HR2 AO4 AI1 AO1 DEO E AFO HR1 TXS SB

C218

C219

R832

R834

R835

R836

R838

C220

R839

C221 C222 C223

C224

C801

C225

C227

C228

C229

R842

C806

C808

R844

R847

C230

R848

C231

R849

C232

C810

C235

C811

C236

C237

C813

C238

C814

R851

C239

C815

R852

+

+

+

+

+

C816

R853

C817

R854

C240

C241

C242

C245

C246

C822

C247

C823

C248

R284

C249

C1

C825 R285

C2

C826

R286

C3

C827

R287

R863

C4

C828

R864C5

C829

R289

+

+

+R865

C6C7C8

C251

C9

C252

C253

C254

C830C2

55

C256

C832

C833

C258

C834

C259

Q101

C835

C805

D2

Q102

C836

C837C838

D5

D6

C260

Q108

C261

Q10

9

D20

1C262

D20

2

C264

D205

C265

D206

C266

Q11

0

Q11

1C8

45Q112

Q113

Q502

Q50

7

Q508

Q50

9G

D SG

D S

Q70

1

Q70

3

Q51

0

Q70

4

Q511

Q70

5

Q512

8C

Q70

6

IC202

Q51

3

Q707

Q514

Q708

Q515

Q709

Q51

7

L504

L505

L507

L508

Q711

Q71

2GS D

Q71

4

L510

L704

L511

L705

L512

L514

L515

L516

L517

L519

R101

R102

R103

R104R105

D11

R112

R113R114 R115

R116R1

17R118

R119

R120

R121

L2L3

R123

R124

R125

R514R520R522

R524

L15

R525

C102

R526

L16

C103

L17

C104

CN701

C105

C106

C107

C108

C109

R530

R531

R532R533R534

IC11

45

8

R535

C111

IC21

45

8

R536

C112

C306

R537

C113

R538 R539

C115

C117

R540R541

R542

R543

R10

R544

C508

R11

R12

R546

C122

R13

R547

R14

R548

C124

R549

R16

R17

C127

R18

R19

C129

C706

R550

C515

R551

C517

R20

R555

TC50

1TX

R556

TC50

2RX

R23

R24

C134

Q1

R559

C135

R26

Q2B

C

ER2

7

R28

R29

R751

CN73

5

C522

C716

CN736 CN737

R560

CN738

R561

C719

CN739

R562

C526 8CL

C527

R31

R565

R32

C720

CN74

0

R1

C721

CN741

R2

R36

C722

CN742

R37

C723

CN743

R38

R4

C724

CN744

R5

R39

C725

CN745

R6

C532

C726

CN74

6

R7

C533

C727

R763

CN74

7

C728R764

CN748

R9

CN749

R766

C537

R767

R40

R768

R41

C539

R769

R42

R43

R44

CN75

0

R45

CN751

R46

CN752

R47

CN75

3

C540

R770

R48

CN75

4

C541

R49

CN755

R772

C543

C544

R774

C545

C739

C546

R776

C547

R777

C548

C549R779

R51

D10

2

D103

R53

D104

D105

C741

D10

6

R56

C743

R58

C550

D10

8

R780

Q204

C551

R781

C745

D10

9

C552

R782

Q20

6

Q20

7

BCE

C553

C747

R783

Q20

8 B C E

C554

C555

R785

C556

R786

C557

C559

C750C751

C752

C753

C754

D50

1

C755

C562

D50

2

C756

L202

D50

3

C563

C757

R793

114E 8C

PTO

RXO NC

NC

BC4

BC3

BC2

BC1

AC

RXI

TXO

TXI

C564

D50

4

C758

R794

L204

D505

C565

C759

R795 D506

C567

D507

R797 C568

D508

R799

IC10

1

IC10

2

1 78

134 5

134

5

134 5

14IC

103

D70

0

C761

IC10

6

C762

D70

2

C570

C764

L211

C571

D51

1

C765

L212

D51

2

C572

C766

D70

6

L213

C767

L214

C574

C768

C769

L216

C576

L217

C577

C579

C770

C771

D71

1D71

2C7

72

C773

C580

L220C774

C581

C775

C776

C778

L713

C780

C779

IC70

0

1 8916

C781

C782

C784C7

87

C788

C789

IC710

C790

IC71

113

4 5

IC713

C794

IC71

4

C795

C785IC717

C797

IC718

C798

IC719

C10

C11

C12

C13

C14

C15

C16

IC722

1

1

45

8

IC7151

1

1

89

16

12 13

24 45

8

IC712

1

45

8

145 8

1

8 9

16

34

5

IC72

513

4 5

C17

R203

IC72

3

OG

G I OI

C18

R204

R205

R207

R209

25 14

113

+ +

+

1144

3637

7273108

109

+

+

+

++

+

+

+

+

+ +

+

+ +

GS

D

+

MO

+

+

C20

C21

C22

C23

CP71

0

R210

C24

C25

XF201(WIDE)

CP71

1

R211

XF202(NARROW)

CP71

2

R212

C27

CP713

R213

R271

R288

TH20

2

CP714

R214

CP7151

100

C29

R217

C30

C31

+

CN201

CN20

2

C33

CN203

C34

R221

C35

C36

C37

C38

R801

C39

R227

R805

R806

R807

C40

R808

R866

R867

R868

C42 C43

C44

C46

C47

R233

C48

R810

R813

R853

C50

R819

C201

C53

C205 TH201C206

R820

C208

C209

R246

R823 R859

R825

R8276

1

IGN

OS2

OS1

ES2

ES1

IRS

C211

X201

C62

C213

D790

D79

1

R253

R254 R255

R831

R256

R257 R258

R259

R837

F100

R260

C800

C74

R261

C75

C65

R262

C802

C226

R263

C803

C844

C77

C804

R264

R265

R841

R266

R267

C807

R843

R268

R269

C809

R845R846

K700

C80

C233

C234

R270R272

C812

17

16

R273

R274

R850

R276

C819

R857

C92

C93

C243

C94

C244

C820

R861R862

C831

C257

D1

D3

Q103 S

G

D

D4

Q104

Q105

Q10

6

Q10

7

BE CBE C

D7

C263

D20

3

D204

NARROW

WIDE

D207

C267

D208

C268

D209

C269

C846

C270

C271

Q501

C272

C273

Q503

C274

Q504

Q50

5

C276

Q50

6

C277

C278

C279

Q70

0GS

D

Q70

2

C280

C281

IC201

1

8 9

16

C282

C283

C284

C285

L501

C286

Q516

C287

L503

C288

Q518

C289

Q51

9

L506

Q71

0

L509

Q71

3

C290

L700

Q520

C291

L701

Q521

Q716

C292

C293

L703

C294

C295

Q719

L706

L513

L707

L708

L709

Q720

TH1

TH2

L710

L711

L712

L520

R106

R107

R108

R109R1

10R1

11

CF201 (D)

CF202 (F)

CF203 (D)

CF204 (F)

R501

R502

R503

R504

R505

R506

CN102+B

R507

R508

R509

R122

L4

R700

L5

R701

L6

R702

R126

L7

R703

L8

C89

C90

R510

R704

L9

R511

R705

R512

R706

R513

R707

R708

R515R709

R516

R517R518 R519R710

R711

R713

L10

L11

R521

R715

L12

L13

R523

L14

R718

C101

R527

R528

CN700

R529

CN703

CN704

R726

R727

R728

C110

C305

R729

C114

C116

R730

C118

R731

C501

C119

C502

C503

C504

C505

C506

C507

C120

C509

C121

C123

C700

R15

C701

C125

C702

C126

C703

C704

C128

C510

X501

C705

C512

C513

C707

C514

C708

C709

C516

R553

R554

C130

R21

C519

C131

R749

R22

C132

R557

C133

R558

C710

X700

C711

CN73

1

C712

CN732

C713

CN733

C520

C714

CN734

C521

C715

R752

C523

C717

R753 C524

C718

R754

C525

R755R7

56

R563

R757

C528

R564

R758

C529

R759

R566

R33

R567

R34

R568

R569

C530

R760

VR70

0

C531

R761

R762

C534

R570

C535

R765

C729

R571

R572

R573

C538

C730

VR1

8T

C731

C732

C733

C734

R771

C735

C542

C736

CN75

6

R773

C737

C738

R775

R778

R50

D101

R52

C740

R54

Q20

1

R55

C742

Q20

2

Q203

C744

Q20

5

R59

C746

R784

C748

Q20

9

G

GD

D

SG

DS

SG

D S

C749

R787

2 1

R788 BU

SYEM

GKE

YA

UX

INH

STO

NTC

NT

DAT

AE 8C PT

OD

ETO

NC

NC

1 14

R789

Q21

0

Q21

1

Q21

2

Q21

3BCE

C560

C561

L201

L203

1 2

L205

L206

L207

L208

R798

L209

D509C5

69

C760

IC10

4O

GI

D70

1

IC105I

O

G

IC107 OIG

OIG

D70

3

L210

D510

D704

TP1

IC108

D70

5

D51

3

C573

D70

7

D51

4

D70

8

L215

1

2

C575

D70

9

D51

5

ME

MIC E

RESE

T

TXD

RXD E

PSW SB IRS

ES2

1 11L218

C578

L219

D71

0

D71

4

D71

5

L221

IC501

1

8 9

16

L222

L223

C777

L224

C584

L225

C585C586

C587

IC701

IC702

IC70

3

IC70

4

1 458

IC705

IC706C593

IC707

C594

IC708

IC709145

8

145

8

C793IC716

C796

C799

CP700

IC72

0

1

189 16

2

R200

CP701

IC721

CP702

R202

CP703

CP70

4

IC72

4

C19

CP70

5CP

706

R206

CP70

7

CP70

8

R208

CP70

9

+

+

+

+

+ +

+

+

RXD3

2526

5051

1

16 17

32

7576

G SD

1

1

1 458

4

4

5

5

8 1

8

8 9

161

12 13

24

+

+

+ +

+

+

+

+

+

+

EP

CP

9C

MB

5C

EP DT CPUL

STR

8CL

8C

RSSIPDET

TEMP2TEMP1

CDET8RC ASQ

8TC

MB

3.3V

GND

GND

5C

1

3 4

5

8R

5C9C

W/N

+

+

+

+

+

CV

5C

8R12CL

Q4G

S

S

D

+

Q5G

S

S

D

J72-0839-19

TX-RX UNIT (X57-6570-10) Component side view + Foil side (J72-0839-19)

TK-7150 PC BOARD

53 54

Ref. No. Address

IC1 4G

IC2 6M

IC101 6E

IC102 5D

IC103 6D

IC104 4A

IC105 4C

IC106 8D

IC107 5D

IC108 6D

IC201 8I

IC202 9I

IC501 11J

IC700 12E

IC701 11C

IC702 9D

IC703 8B

IC704 12D

IC705 13C

IC706 11E

IC707 10E

IC708 12E

IC709 12E

IC710 11C

IC711 13B

IC712 11E

IC713 10E

IC714 11F

IC715 9E

IC716 10E

IC717 9B

IC718 9D

IC719 8E

IC720 6B

IC721 8E

IC722 8C

IC723 7E

IC724 11F

IC725 13E

Q1 6I

Q2 6G

Q4 5H

Q5 5L

Q101 4E

Q102 4D

Q103 4D

Q104 6E

Q105 5E

Q106 6E

Q107 5E

Q108 4D

Q109 5E

Q110 5D

Q111 4D

Q112 4C

Q113 4C

Q201 8K

Ref. No. Address

Q202 8K

Q203 9I

Q204 9J

Q205 8J

Q206 8K

Q207 9P

Q208 11M

Q209 11O

Q210 11O

Q211 12O

Q212 12O

Q213 9Q

Q501 10I

Q502 12G

Q503 10I

Q504 10I

Q505 12G

Q506 12G

Q507 11J

Q508 11G

Q509 10J

Q510 10J

Q511 10G

Q512 11K

Q513 10J

Q514 10K

Q515 10K

Q516 11K

Q517 12M

Q518 12K

Q519 12K

Q520 11I

Q521 12K

Q700 9C

Q701 3B

Q702 12D

Q703 3D

Q704 3C

Q705 3D

Q706 3C

Q707 12F

Q708 12E

Q709 10D

Q710 7D

Q711 9C

Q712 6C

Q713 12D

Q714 6C

Q716 3E

Q719 9B

Q720 9A

D1 3J

D2 6L

D3 6Q

D4 7Q

D5 4R

D6 3R

Ref. No. Address

D7 6G

D11 6N

D101 3F

D102 4D

D103 4D

D104 4D

D105 4D

D106 4E

D108 5C

D109 5C

D201 9K

D202 9K

D203 8F

D204 8H

D205 9L

D206 9O

D207 12Q

D208 10Q

D209 8Q

D501 11H

D502 10H

D503 11H

D504 10H

D505 11H

D506 11H

D507 10H

D508 10H

D509 11G

D510 11G

D511 11I

D512 11G

D513 10K

D514 10K

D515 12J

D700 4C

D701 3E

D702 3E

D703 3C

D704 10D

D705 3B

D706 3B

D707 3C

D708 3C

D709 3B

D710 2D

D711 11F

D712 11E

D714 5E

D715 3D

D785 13J

D786 13J

D787 9B

D788 9B

D789 10F

D790 10E

D791 13K

D793 3E

Component side

Foil side


Connect 1 and 6

A B C D E F G H I J K L M N O P Q R S T

1

2

3

4

5

6

7

58

SCHEMATIC DIAGRAM TK-7150Note : Components marked with a dot (•) are parts of layer 1.

4.76V

13.20V

13.49V

4.76V4.67V

ON:1.76V

8.29V

4.76V

8.29V

4.94V

7.48V

4.76V 8.88V

4.76V

5.96V 5.96V

4.76V

ON:1.90V

CN901E40-5538-05

1

2

C916

100p

C915

100p

R906 1k

R907 1k

R902

100k

R9

23

1k

R9

24

1k

R9

25

1k

R9

28

1k

R9

32

1k

R9

33

1k

R935 47k

R936 47k

R937 47k

R938 47k

R939 47k

R940 47k

TP2TP1

D906DA204U

D904DA204U

D905DA204U

D903DA204U

R9

17

47

k

R9

16

47

k

C9

04

10

00

p

R9

18

47

k

R91347k

C9

28

0.0

1u

C9

09

10

0p

C9

24

10

u1

0

C9

18

0.0

1u

C9

21

0.0

1u

C9

23

0.0

22

u

R910100k

C9

29

10

00

pR

91

45

60

D90702CZ9.1(X,Y)

R9

15

0

R9

31

2.7

k

R9

34

2.7

k

C9

33

0.0

1u

C9

35

10

00

p

C9

31

0.0

1u

IC90430622M4A-443GP

1P94

2 P933 P924 P915 P906 BYTE7 CNVss8 P879 P86

10 RESET11 Xout12 Vss13 Xin14 Vcc15 NMI16 P8417 P8318 P8219 P8120 P8021 P7722 P7623 P7524 P7425 P73

26

P7

22

7R

XD

22

8T

XD

22

9T

XD

13

0R

XD

13

1C

LK

13

2R

TS

13

3T

XD

03

4R

XD

03

5P

61

36

P6

03

7P

57

38

P5

63

9P

55

40

P5

44

1P

53

42

P5

24

3P

51

44

P5

04

5P

47

46

P4

64

7P

45

48

P4

44

9P

43

50

P4

2

51P41

52P40

53P37

54P36

55P35

56P34

57P33

58P32

59P31

60Vcc

61P30

62Vss

63P27

64P26

65P25

66P24

67P23

68P22

69P21

70P20

71P17

72P16

73P15

74P14

75P13

76

P1

2

77

P1

1

78

P1

0

79

P0

7

80

P0

6

81

P0

5

82

P0

4

83

P0

3

84

P0

2

85

P0

1

86

P0

0

87

AN

7

88

AN

6

89

AN

5

90

AN

4

91

AN

3

92

AN

2

93

AN

1

94

AV

ss

95

AN

0

96

AV

ref

97

AV

cc

98

P9

7

99

P9

6

10

0P

95

J901E08-0877-05

15263748

IC901TA7805F

3

GND

1IN

2OUT

IC902RH5VL42C

3

GND

2VDD

1OUT

D9

12

B3

0-2

19

3-0

5

D9

15

B3

0-2

19

4-0

5

Q906DTC114EE

2SJ243Q901

2SD1760Q903

C917

100p

C9

10

10

0p

C9

07

10

00

p

D902DA204U

R905 0R904 0

C9

25

10

00

p

C9

34

10

00

p

Q907DTC114EE

C9

38

10

00

p

D914B30-2254-05

D913B30-2254-05

D911B30-2254-05

Q908DTC114EE

C9

39

10

00

p

D910B30-2254-05

D908B30-2254-05

D909B30-2254-05

C9

30

10

00

p

Q904DTC114EE

R927

150

R926

150

C9

32

10

00

p

Q905DTC114EE

R920

56C

90

51

00

p

C9

14

10

00

p

C9

06

10

0p

L9

01

1u

L9

02

1u

2SK1824Q902

C9

22

6p

R9

08

47

k

R909

4.7k

C9

19

0.0

1u

C9

26

27

p

C9

27

27

p

R948

100k

X901L77-1863-05

12MHz

CN902E40-6140-05

1

2

3

4

5

6

7

8

9

10

11

R9

41

47

k

Q909DTC144EE

Q910DTC144EE

R9

42

4.7

k

R9

43

33

k

R944 470

VR901R31-0630-05

R945

6.8

R9

22

33

k

TP4

Q911DTC144EE

C9

41

10

00

p

R9

19

33

k

R946 2.2

R947 2.2

C9

42

10

00

p

R949

1k

R950

220k

C9

43

0.0

1u

D9

16

02

DZ

18

(X,Y

)

C9

44

10

00

p

R9

51

1k

CN906

E40-5752-05

1

2

3

4

5

W1E37-1057-05

1

2

3

4

5

S1S60-0423-05

3

5

2

6

1

4

R9

53

10

0k

R9

54

10

0k

R9

55

10

0k

R9

52

10

0k

D917

MINISMDC020

D9

18

02

DZ

18

(X,Y

)

C9

01

10

0p

C9

03

0.0

1u

C9

02

10

00

pR956 1k

R957 1k

R959 1k

R958 1k

R9

60

4.7

k

C9

11

10

u1

0

C9

12

10

u1

0

5

4

3

2

1

CN905E40-5823-05 1 2 3 4 5 6 7 8 9

10

$C

90

8

$C

91

3

$R921

$R

94

1

$C

94

0

$R

94

21

k

ME

MIC

HK

DM

ME

BLCSB

DM

PTT

MIC

E

HKPF1

HK

PTT

DM

BLC

ES2

IRS

SB

E

PSW

RXD

TXD

E

ME

MIC

IRS

ES2

POWER

TX BUSY

5V

TXD

RXD

VOL

DISPLAY UNIT (X54-3400-10) (A/2)

RESET

(X54-3400-10) (B/2)

PF2 PF3 PF4 PF5 PF6

NC

LE

DK

LE

DA

DIS

P

DO

DI

CL

CE

VC

C

E

LCD ASSY

D902-906 :DA204U

D907 :02CZ9.1(X,Y)

D908-911,913,914 :B30-2254-05

:B30-2193-05D912

:B30-2194-05D915

:02DZ18(X,Y)D916,918

:MINISMDC020D917

:2SJ243Q901

:2SK1824Q902

:2SD1760Q903

:DTC114EEQ904-908

Q909-911 :DTC144EE

IC901 :TA7805F

IC902 :RH5VL42C

IC904 :30622MA4A-443GP

CN703 1

11

TX

-RX

UN

IT

X57-6

570-1

0

SURGE PROTECTORD902-906

VOLTAGE REFERENCE

KEY Backlight

D908-910 D911,913,914KEY Backlight

TX lightD912

RX lightD915

D916SURGEPROTECTOR

CURRENT PROTECTOR

VOLTAGE REGULATOR

VOLTAGE DETECTOR

CPU

MIC SWITCH

DC SWITCH

CURRENT DRIVER

DC SWITCH

DC SWITCH

DC SWITCH

Q906,907

DC SWITCH

INVERTER

INVERTER

DC SWITCH

SP OP OSA BMONCALL SCN

1.77V

4.99V

5.00V

5.00V

4.99V

4.99V

4.99V

13.19V

4.96V

5.00V

3.30V

3.30V

3.30V

4.98V

3.30V

1.77V

3.30V

1.77V

3.30V

1.77V 3.30V

3.30V

1.77V

3.30V

1.77V

1.77V

TX-RX UNIT (X57-6570-10)

CD

ET

TE

MP

1

TE

MP

2

AS

Q

RS

SI

UL

UL

PDET

TEMP1TEMP2

ASQRSSI

+B

PSW

W/N

TXO

INT

8CRXO

DI

SBC

TXISTON

8TC

RXI

8RC

DI

RXORXI

8TC

TXISTON

8RC

8C

INT

TXO

W/N

BCLKR1

RST

DEOSB

3.3

1.8

5MD5MD

PD

ET

+B

RST

DI

VOLTAGEREDUCTION

D707-709

SURGE PROTECTOR

SURGE PROTECTOR

D710,715

SHIFT REGISTER

CPU

RS232CTRANSCEIVER

VOLTAGE DETECTOR

EEPROM

FLASH ROM

BUS TRANSCEIVER

IC706

OR GATE

IC707-709

DSP

INVERTER

DC SWITCH

Q700

DC SWITCH

DC SWITCH

DC SWITCH

DC SWITCH

DC SWITCHQ713

DC SWITCH

DC SWITCH

Q703-706

SURGE PROTECTORD700-703,705,706

DETO

STRSTR

DETO

12.288

ME ME

CBAA

BC

A

CB

DEOMI2MI2

CURRENT PROTECTOR

BS BS BS

AFO

STON

TXORXI

D

D

D

D

D

D

D

D

D D

D

D

DD D

D

DD D

+BUL

RSSI

STR

STR

8TC

8TC

INT

HR2

HR2

BCLKR1TEMP1

SBC

8RC

8RC

1.8D 1.8D

1.8D

PDET

DEO

12.288

RST

RST

TXD2D

RXD2D

TEMP2

ASQ

3.3D 3.3D

3.3D3.3D

DETO

SB

SB

PSW

HR1

HR1

MI2

MI2

8C

5MD

5MD

W/N

W/N

TXI

ME

RXO

5C

5C

5C

5C

R701

47k

C724

0.0

1u

C733

1000p

R766

4.7k

IC707TC7WH32FK

11A

21B

32Y

4GND

52A

62B

71Y

8VCC

R763

47k

R783

47k

C729

1000p

D707

DA

204U

C754

0.0

1u

R768 47k

R761

47k

IC700BU4094BCFV

1 STRB

DATA

CLK

Q1

Q2

Q3

Q4

8VSS

9

16

D700

1SS355

C759

1u

C732

1000p

R718

47k

C707

0.01u

C743

0.1

u

C706

0.01u

R778

1k

Q704DTD114EK

C722

0.0

1u

R774

4.7

k

C740

1000p

IC705AT29C040A-12TI

1A11

A9

A8

A13

A14

A17

WE

VCC

A18

A16

A15

A12

A7

A6

A5

16A4

17A3

A2

A1

A0

Io0

Io1

Io2

GND

Io3

Io4

Io5

Io6

Io7

CE

A10

32oE

C715

1u

R729 0

C741

0.0

1u

C752

0.0

1u

R710

47k

R703 0

C701

0.0

1u

R706

1.5k

Q706DTD114EK

D705

DA

204U

R777

47k

IC708TC7WH32FK

11A

21B

32Y

4GND

52A

62B

71Y

8VCC

C757

1u

IC703ADM202EARN

1

89R2OUT

T2IN

T1IN

R1OUT

R1IN

T1OUT

GND

16VCC

R767 47k

C755

0.0

1u

R762

1k

R752

47k

R705

1.5k

C750 1u

C744

100p

C714

0.1

u

C723

0.0

1u

C70522p

CN701

E40-9370-05

1

2

3

4

5

6

7

8

9

10

11

12

13

14

R749

47kR

709

47k

R728 0

C718 0.1u

D708

DA

204U

D701

DA

204U

L705

C737

100p

C720

1u

C711

1u

C753

0.0

1u

R756

1k

R759

47k

IC702BU4094BCFV

1 STRB

DATA

CLK

Q1

Q2

Q3

Q4

8VSS

9

16

R772

47k

R770 47k

C735

1000p

R776

47k

R764

47k

R702

4.7k

J700E58-0494-05

1

2

3

4

5

6

7

8

9

11

10

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

R781

22k

R765

1k

R755

1k

C7160.01u

R751

0

D703

DA

204U

C719

1u

C751 0.01u

C726

0.0

1u

C70422p

C738

1000p

IC711TC7SU04FU

1N

C2

IN3

GN

D4

OU

T

5V

CC

C709

1u 25

R780

47k

R754

0

R727

47k

R773

1k

Q701DTC114EE

C734

100p

R713

47k

R70733k

R775

47k

D706

DA

204U

L700

C731

100p

D704

MA2S111

R758

0

D702

DA

204U

C700

0.0

1u

D709

DA

204U

IC70130620M8A-5H1GP

1P94P93

P92

P91

P90

BYTE

CNVss

P87

P86

RESET

Xout

Vss

Xin

Vcc

NMI

P84/INT2

P83/INT1

P82

P81

P80

P77

P76

P75

P74

25

P73

26

P72

RxD

2

TxD

2

TxD

1

RxD

1

P65

P64

TxD

0

RxD

0

P61

P60

P57/R

DY

P56/A

LE

P55/H

OLD

P54/H

LD

A

P53/B

CLK

RD

P51/W

RH

/BH

E

WR

P47

P46

CS

1

CS

0

A19

50

A18

51

A17A16

A15

A14

A13

A12

A11

A10

A9

Vcc

A8

Vss

A7

A6

A5

A4

A3

A2

A1

A0

P17

P16

P15

P14

75P13

76

P12

P11

P10

D7

D6

D5

D4

D3

D2

D1

D0

AN

7

AN

6

AN

5

AN

4

AN

3

AN

2

AN

1

AV

ss

P100/A

N0

Vre

f

AV

cc

P97

P96

100

P95

C703

3p

IC706TC74LVX4245FS

1 VCCA

DIR

A1

A2

A3

A4

A5

A6

A7

A8

GND1

12

GND2

13GND3

B8

B7

B6

B5

B4

B3

B2

B1

G

VCCB1

24VCCB2

C749

1000p

C727 1u

R700

1k

Q705DTD114EK

IC704AT24128N10SI27

1A0

A1

A2

4GND

5SDA

SCL

TEST

8VCC

R760

1k

C717

0.1

u

C710

1u 25

C708

0.01u

C721

1u

C739

1u

C747

0.0

1u

C742

1000p

R769 100

R715

47k

IC709TC7WH32FK

11A

21B

32Y

4GND

52A

62B

71Y

8VCC

R70447k

R70833k

R757

47k

CN700

E40-9370-05

1

2

3

4

5

6

7

8

9

10

11

12

13

14

C745

1u

C730

100p

C713

1u

25

R771

1k

C725

1u

C736

1000p

R779

47k

R782

100k

Q702DTC144EE

C746

100p

C728 0.01u

L703

IC710

320VC5402PGE

136

37NC7NC8

HCNTL0

VSS6

BCLKR0

BCLKR1

BFSR0

BFSR1

BDR0

HCNTL1

BDR1

BCLKX0

BCLKX1

VSS7

HINT/TOUT1

CVDD3

BFSX0

BFSX1

HRDY

DVDD3

VSS8

HD0

BDX0

BDX1

IACK

HBIL

NMI

INT0

INT1

INT2

INT3

CVDD4

HD1VSS9

NC9

72

NC10

73

NC

11

NC

12

DV

DD

4

VS

S12

CLK

MD

1

CLK

MD

2

CLK

MD

3

NC

13

HD

2

TO

UT

0

EM

U0

EM

U1/O

FF

TD

O

TD

I

TR

ST

TC

K

TM

S

NC

14

CV

DD

5

HP

IEN

A

VS

S13

CLK

OU

T

HD

3

X1

X2/C

LK

IN

RS

D0

D1

D2

D3

D4

D5

A16

VS

S14

A17

108

A18

109

A0

A1

A2

A3

HD6

A4

A5

A6

A7

A8

A9CVDD7

NC17

144

NC18

R753

47k

C748

100p

C758

1u

C756

1u

C702

0.1u

Q703DTD114EK

R8420

C830

1000p

R843

47k

R726

47k

CP

700

100

CP

701

100

CP

702

100

CP

703

100

CP704 100

CP705 100

CP706 100

CP707 100

R711

100CP708 100

CP709 100

CP710 100

CP711 100

CP712 100

CP713 100

CP714 100

2SK1824Q713

X700L77-1896-05

12.288MHz

K700S76-0434-05

Q719DTC114YE

Q720DTC114YE

R86147k

R86247k

RXD3

Q716DTC114EE

C804

1000p

R805

10k

R84547k

R846

47k

L706

L707

L708

L709

L710

L711

L712

L701

R806

47k

R807

47k

R801

47k

R730 0

R731 0

R850

10k

C712

1u

25

CP715

100

D71002DZ18(X,Y)

R787 0

R851 0

R852

0

D71502DZ18(X,Y)

R857

10k

TP

D793

MINISMDM110/16

C845

10u

10

C846

1000p

CN102

TP1

2SK1824Q700

C831

0.1u

BF

SR

0

XF

BCLKR1

BCLKR0

BDR0

BDX0

HD7

HD0

HD0

HD1

HD2

HD3

HD4

HD5

HD6

HD7

HD1

HD

2

HD

3

HD4

HD6

HD5

L704

D0

D1

D2

D3

D4

D5

D6

D7

A4

A6

A5

A7

A11

A13

A14

A17

A12

WE

A8

A9

A15

A16

A18

D0

D2

D1

D7

D6

D4

D3

D5

A0

A1

A2

A3

A10

CE

OE

A0

A1

A3

A2

A4

A5

A6

A7

A8

A9

A10

A11

A12

A15

A16

A18

A17

A13

A14

OE

WE

CE

AI4

RX

D

TX

D

AI3

AI2

AI1

IGN

AO1

AO2

AO3

AO4

RX

D3

RX

D2

TX

D2

RX

D2

TX

D2

TX

D3

RX

D3

AI2

AI3

AI1

AO

1

AO

2

AO

3

AI4

AO

4

LD

CP

EP

DT

CK

AM

$R726

$R725

TX

D3

$R

833

$R

866

R863

68k

IC725PST9140NR

1N

C2

VE

E1

3V

EE

24

OU

T

5V

CC

QS

Q’S

Q8

Q7

Q6

Q5

OEVDD

QS

Q’S

Q8

Q7

Q6

Q5

OE

VDD

NC

1N

C2

VS

S1

DV

DD

1

A10

HD

7

A11

A12

A13

A14

A15

NC

3

HA

S

VS

S3

NC

4

CV

DD

2

HC

S

HR

W

RE

AD

Y

PS

DSIS

R/W

MS

TR

B

IOS

TR

B

MS

C

XF

HO

LD

A

IAQ

HO

LD

BIO

MP

/MC

DV

DD

2

VS

S5

NC

5N

C6

CVDD6

NC16

HDS1

VSS16

HDS2

DVDD

A19NC15

VSS15

DVDD5

D6

D7

D8

D9

D10

D11

D12

HD4

D13

D14

D15

HD5

NC

NC

DETO

PTO

8C

E

DATA

TCNT

STON

INH

AUX

KEY

EMG

BUSY

E

8C

PTO

RXO

NC

NC

BC4

BC3

BC2

BC1

AC

RXI

TXO

TXI

TXD3

AO2

E

AI3

AI2

AFO

HR1

DI

AI4

NC

RXD3

ME

MI2

HR2

AO4

AO3

AO1

DEO

E

AI1

TXD2TXS

RXD2SB

E

C1+

V+

C1-

C2+

C2-

V-

T2OUT

R2IN

IC702

SHIFT REGISTER

TSRQPONMLKJIHGREDCBA

1

2

3

4

5

6

7

59

TK-7150 SCHEMATIC DIAGRAM

13.57V

13.56V

13.53V

1.23V

7.92V7.44V

0.60Vpp

8.12V

R:8.00VT:0V

R:7.38VT:8.00V

R:0VT:8.06V

R:4.96VT:0V

5.00V

1.80V

3.30V

R:8.06VT:7.35V

R:0VT:7.97V

R:8.06VT:0V

R:0VT:4.91V

4.97V

5.00V3.30V

5.00V

4.99V 5.00V

4.95V

0.52V

6.08V

7.83V7.87V

14.78V

14.99V

12.02V

11.37V 11.32V

11.28V

10.64V

13.29V

5.00V

4.84V

4.85V

5.60V

5.00V

0.28VppSTD-53dBm

4.89V

W:0VN:4.74V

0.03V

W:4.71VN:0V

W:0VN:4.74V

7.94V

3.60V 7.20V7.02V

2.90V

R:0VT:4.84V

R:2.76VT:0V

7.86V

7.60V

1.40V

4.70V

0.72V

+3dBm

7.70V 6.59V

2.19V2.22V

1.20V

1.65V2.53V

3.72Vmax

6.20Vmax

3.10Vmax1.60V

0.82V

6.77V

7.88V

0.26V7.91V

0.75V

0.48V

7.89V

6.79V

W:2.71VN:0V

W:0VN:2.74V

8.06V

14mVpp

0.86Vpp4.97V 180mVpp

3.29V

0.25Vpp

90mVpp

88mVpp

4.97V

4.97V

8.06V

1.38Vpp 4.94V

4.97V

1.38Vpp

4.97V

1.55Vpp

4.97V

5.00V

4.97V

8.06V

IRS

ES1

OS2

ES2

IGN

OS1

E

IRS

RESET

TXD

11

RXD

ES2

1

PSW

(X5

4-3

40

0-1

0)

(A/2

)

MIC

E

DIS

PL

AY

UN

IT

ME

SB

CN902

D1 :ZSA5A27

:02DZ6.2(Y)

:MA4PH633

:XB15A709

:MA742

:1SS226

:1SS355

D2

D3

D4

D5,6,202,711,712

D7

D11,104-106,201,700

D101 :DSA3A1-FK

D102,710,715 :02DZ18(X,Y)

D103 :02DZ15(X,Y)

D108,701-703,705-709

D109

:DA204U

:02DZ10(Z)

:DAN235ED203-206

:1SV228D207-209

:1SV282D501-508

D509,510,714,794 :1SS388

:1SV278D511

:02DZ12(Y)D512

:HVC131D513,514

:MA2S111D515,704

:02DZ5.1(Y)D785-790

:MINISMDM075/24D791

:MINISMDM110/16D793

IC1,2,712,715,716 :TA75W01FU

IC101,103,725 :PST9140NR

IC102 :TC4013BF(N)

IC104 :TA7808S

:TA7805FIC105

:XC62FP3302PIC106,108

IC107 :XC62FP1802P

IC201 :TA31136FN

IC202 :TC7S66FU

:ADF4111BRUIC501

:BU4094BCFVIC700,702

IC701 :30620M8A-5H1GP

IC703 :ADM202EARN

:AT24128N10SI27IC704

:AT29C040A-12TIIC705

:TC74LVX4245FSIC706

:TC7WH32FKIC707-709

:320VC5402PGEIC710

:TC7SU04FUIC711

:AK4550VTIC713

:TC75W51FUIC714,719

:BU4053BCFVIC717

:M62364FPIC718

:TDA8561QIC720

:LMC7101BIM5IC721

:TA75S01FIC722

:NJM78L05UAIC723

:2SC3356(R24)Q1

Q2,207,208,213 :2SC3357

Q101,102,104,105, :DTC114EE

Q103 :2SJ506(S)

Q106,107 :2SB1132(Q,R)

Q108,111,201 :DTA114EE

Q109,112 :DTA114YE

Q110 :DTC114TE

Q113,719,720 :DTC114YE

Q204 :2SC4617(S)

Q205 :DTA144EE

:2SC4215(Y)Q206

:2SK508NV(K52)Q209-212,507,509

:2SC4116(BL)Q501,503,504

:2SK1215(E)Q502

:2SC4738(GR)Q505

:2SA1832(GR)Q506,518

:2SC5108(Y)Q513,515,516

:DTC144EEQ519,521,702,709,714

:2SK1824Q700,713

:DTD114EKQ703-706

:2SC4116(Y)Q707

:2SA1586(Y,GR)Q708

:2SD1757KQ711

:2SJ243Q712

701,710,716

TEMP2TEMP1

UL

RSSIASQ

PDET

+B +B

ASQ

TXI

RXO

DI

8C

TXORXI

STONW/N8RC

8TC

INT

SBC

PSW PSW

RXO

TXISTON

TXO

8C

DI

TEMP1TEMP2 TEMP2

PSWTEMP1

BCLKR1 BCLKR1

SB

PDET

RSTRSTRST

5MD5MD

MUTE

DEO

RSSISB

PDET

MB

STON

202,203,514,

DI

1

2

3

5

6

4

5

6

SURGE PROTECTORD1

VOLTAGEPROTECTION

ANT SWITCH

ANTSWITCH

D4D11

SURGE PROTECTOR

D5,6

RF DETECTOR

TEMPERATURECOMPENSATION

D101 PROTECTION OF REVERSE CONNECTION

D102,103

VOLTAGEREFERENCE

DC SWITCH

D104,106

DC SWITCHD105

SURGEPROTECTOR

VOLTAGEREFERENCE

DS SWITCH

D201

NOISEDETECTION

WIDE/NARROWSWITCH

D203,204

WIDE/NARROWSWITCH

D205

WIDE/NARROWSWITCH D207-209

BPF TUING

D501-508

FREQUENCY CONTROL

D509,510

VOLTAGE DOUBLER

D512

VOLTAGEREFERENCE

MODULATORD511

RF SWITCH

D513,514

AF DETECTOR

D711,712

DCSWITCH

SURGEPROTECTOR

D785,786

SURGE PROTECTOR

D787,788

SURGEPROTECTOR

D789

SURGEPROTECTOR

CURRENTPROTECTOR

DC AMP

VOLTAGEDETECTOR

D Flip-Flop

VOLTAGEDETECTOR

VOLTAGEREGULATOR

IC104-108

FM IF SYSTEM

MULTIPLEXER

PLL

AF AMP

CODEC

MIC AMP/AGC

BUFFERAMP

ANTI-ALIASINGFILTER

MULTIPLEXER

D/A CONVERTER

AF AMP

AUDIO POWER AMP

DC AMP

AF AMP

VOLTAGEREGULATOR

IC723

MULTIPLEXER

RF AMP

RF AMP

DRIVER AMPFINAL AMP

DC SWITCH

SWITCH

DC SWITCH

DC SWITCH

Q104-107

DC SWITCH

Q108-113

W/N SWITCH

W/N SWITCH

W/N SWITCH

NOISE AMP

Q204

W/N SWITCH

IF AMP

PRE IF AMP

Q207

RF AMP

Q208

MIXERQ209-212

RF AMP

ACTIVE FILTER

Q501,503,504

OSCILLATOR

Q502

DC SWITCH

Q505,506

TX OSCILLATOR

RX OSCILLATOR

AVR

TX/RX SW

RIPPLE FILTER

TX/RX SW

BUFFER AMP

INVERTER

BUFFER AMPQ515

AMP

RIPPLE FILTER

DC SWITCH

DC SWITCH

DC SWITCH

DC SWITCH

INVERTER

DC SWITCH

DC SWITCH

DC SWITCHDC SWITCH

INVERTER

MIC GAIN SWITCHQ707,708

VOLTAGEREGULATOR

Q508,510-512,517,520 :2SC4116(GR)

IGNIGN

IGN

DETO

STR STR

DETO

ME ME

ME ME

ABC

BC

A

DEO

MI2MI2MI2MI2

RXI RXI

:PD55003SQ4

Q5 :RD70HVF1-01

TX-RX UNIT (X57-6570-10)

DI

BS BS BS

AFO AFO AFO

IC724 :TC4W53FU

MB

-t

-t

D

D

-t

-t

+B

+B

+B

MO

3.3A

3.3A

3.3

3.3

3.3

UL

UL

RSSI

AABBCC

TXO

INT

TEMP1

TEMP1

TEMP1

SBC

1.8

1.8

1.8

8T8T 8T

8C

PDET

PDET

PDET

9C

DEO

RST

TEMP2

TEMP2

TEMP2

MB

8CL

8CL

8R

8R

8R

8R

8R

PSW

PSW

MUTEMUTE

8C

8C

8C

8C

8C

5MD

W/N

W/N

TXI

MICMIC

IGN

SB

SBSB

SB

RXO

5C

5C

5C

5C

5C

5C

5C

5C

STON

R110

4.7

k

C132

1000p

C116

0.1

u

R104 330k

C113

0.1

u

C102

0.0

47u

C122

0.1

u

C114

470p

C120

0.0

47u

R109

47k

2SB1132(Q,R)Q107

R107

47k

C133

4.7

u16

C126

100p

R101

470k

D101

DS

A3A

1-F

K

R108

47k

C115

0.0

47u

C121

1000p

C124

100p

R111

4.7

k

2SJ506(S)Q103

C104

100p

C119

1u

C131

10u

10

C109

470p

C127

4.7

u16

2SB1132(Q,R)Q106

C123

0.1

u

C107

470p

R102

390k

R105330k

C110 470p

R106

4.7

k

C125

100p

C118

1u

C130

10u

10

C103

470p

C128

10u

10

R103

470

C129

10u

10

C117

1u

C111

0.1

u

R266

100k

R210

2.2

k

R10

2.2

k

C251

33p

C5191000p

R238

1k

2SC3357Q208

R53810

R212

270k

C293

27p

C5

1000p

C21327p

C74

22p

R54

270

C572

1000p

L427n

L512

100u

R567

2.2

k C259

15p

C57715p

C28010p

CN201E40-5538-05

12

C252100p

C506

1000p

R547

4.7

k

C5300.1u

D5071SV282

C565

1000p

D5101SS388

C253

0.0

1u

R23

100k

C538

470p

C5430.75p

L1247n

C5094.7u 16

C2881000p

R564

100

C515

0.1

u

R222

10k

C2030.1u

R2485.6

C75

15p

R207

56

2SK508NV(K52)

Q210

C48

0.5

p

R536

390C

547

9p

R527

12k

C524

0.1u

2SK508NV(K52)Q507

R4547k

R216

22k

R233

2.2

k

D202MA742

C224

0.0

1u

C514

1000p

C1R24 10k

1000p

R260

10k

C21

82p

R226

47k

C264

27p

C218

0.0

1u

R5260

C2

1000p

R1

R16

R17

R27

470k

R28

10k

100k

R19

56k

0.0

03

1k

R7

47

C53356p

C208

270p

C11

1000p

L2031u

C242

1p

C245

47p

R509 10

C525

0.1u

VR

147k

D204DAN235E

R262270

R202

39k

C550

1000p

L511 50n

2SC4738(GR)Q505

C295

1000p

R521k

C212

0.0

1u

R531

10k

R203

330k

C7

1000p

L11

47n

R44

120

D207 1SV228

R514

47

R2640

C13

1000p

C10

39p

R544

220k

R267

100k

C4

10p

L224

82n

C575

15p

D205

DAN235E

R236

27

C243

0.0

1u

R2340

R253

100

L209

R229

2.2

k

C546

9p

2SC4116(BL)Q503

L225100n

L15

110n

C221

18p

R245

22

L202

1u

C291

220p

C93

470u

25

C531

27p

C559

1000p

XF202

Narrow44.85MHz

R252

820

R55

270

D5061SV282

D6MA742

R5130

C23

820p2SA1832(GR)Q506

R263270

C505

1000p

R219

6.8

k

C570

1000p

C539

15p

R542

4.7

k

C31000p

C503

10u

6.3

C255

1000p

C228

10p

R563

220

C39

39p

R228

2.2

k

C537

0.1

u

C283

27p

L503

5.6

u

R5251k

C214

0.1

u

R40

0

L3

68n

L215

180n

L204

10u

C12

1000p

R548

10k

C272

27p

C36

27p

C285

1000p

L218L39-1272-05

C47

0.5

p

R555

33k

C32

1000p

2SK508NV(K52)Q209

2SC4617(S)Q204

R553

100

C16

1000p

C181000p

C292

220p

D5091SS388

C231

47p

C557

0.0

1u

C236

1p

C247

1000p

D503

1S

V282

R516

47k

2SC5108(Y)Q516

L501

R26947

R25810

C22

1000p

L220

33n

2SC3357Q207

IC201

TA31136F

N

123456789

AF

OU

T

10

QU

AD

11

IFO

UT

12

RS

SI

13

N-D

ET

14

N-R

EC

15

GN

D

16

MIX

IN

L520

100n

R51

1k

C266

15p

L1347n

R1518

L217

33n

R528

68k

R208

4.7

k

C89

30p

X201

44.3

95M

Hz

R240

1.8

k

C202

1000p

C257

68p

C522

470p

D3

MA4PH633

D203DAN235E

R256

10k

C534 3p

C227

100p

R546 33

R270

12

R554

47

C5210.47u 25

R5331.5k

D206

DAN235E

C256

1000p C51

1000p

C281

220p

C238

3p C265

3p

C62

10p

D4

XB

15A

709

2SK508NV(K52)Q509

R529

12k

C526

1000p

R521560

R206

1.5

k

C501

1000p

C267

0.0

1u

C512

0.0

1u

C5134.7u16

C585

1000p

C241

1p

C2589p

L219

6.8u

R518

2.7

k

R502

220

C1722p

C578

1000p

TC

502

8p

C246

47p

L50639n

C561

47u

20

C563

0.0

1u

L2

68n

C552

1000p

C52710u 10

C274

220p

R230

1k

2SC4215(Y)Q206

C232

47p

R33

100k

C38

820p

C277

0.0

1u

C248150p

C34

240p

C20

33p

C54133p

D501

1S

V282

C289

27p

R53

470

R25710

C5681000p

R48

270

L6 47n

C517

0.1

u

R29

0

C27

120p

R39 10k

C45

1000p

R25410

C535

15p

D505 1SV282

C234

0.0

1u

R37

100k

C529 3p

C6

1000p

R232

2.2

k

R556

10k

D201

1S

S355

L205

C219

10u

6.3

L1447n

C249

0.0

1u

2SK508NV(K52)

Q212

C101

1000u

25

C230

0.01u

D208 1SV228

2SK1215(E)Q502

R543

4.7k

R508 10

R225

1k

R246

47

R250

820

C67

0.0

47u

C276

27p

C14

1000p

R539100

C284

0.0

1u

CN202E40-5538-05

12

C507

0.3

3u

35

2SC4116(GR)Q510

L510

35.5

n

C226

8p

C549 15p

2SC4116(BL)Q501

C555

1000p

C235

1p

C532

68p

R537220

C551

15p

C510

10p

C286

12p

C43

0.5

p

R205 3.3k

R38

10k

C278150p

R53022k

R31 100

R13

18

C31

1000p

L216

33n

R21327k

R215

6.8

k

C2690.01u

C504

0.0

68u

C56415p

C233

0.0

1u

C49

1000p

C586

1000p

C25

47p

TH

201

R550

0

R523

56

R520

150

R566

33

R220

22k

L50939n

C282

220p

Q203DTC114EE

L221L39-1272-05

R562

330

R227

2.2

k

R503

560

L222L39-1272-05

2SC5108(Y)Q515

C5671000p

L922n

R2390

L21110u

R50

680

R24110k

R2515.6

C8

1000p

R2424.7k

R244

33

R5341k

C508

0.1u

C29010p

C528

15p

C5691000p

C2680.01u

C222

15p

R49

270

R273

1k

R501

22

C223

1000p

2SK508NV(K52)Q211

R221

15k

R209 330k

R5584.7k

D504

1S

V282

R532100k

C260

27p

D5081SV282

R11

100

R268

220

C21510u6.3

L22310u

R6

470

L207

D1

ZS

A5A

27

C294

0.0

1u

2SC4116(GR)Q511

C239

3p

R507 10

R274

100k

L214

39n

C2623p

R25510

R559

100

L513100u

Q201DTA114EE

C562

1000p

R26

0

C27310p

D2

02D

Z6.2

(Y)

C54

4p

R249

820

R5

4.7

k

R214

15k

L8

47n

R224100

C204

1000p

R522

22

R140

C502

2.2

u10

C225

0.1

u

R36

330k

R235

56

R231

2.2

k

D71SS226

L213

120n

C548

15p

R32100k

C42

0.5

p

2SC3357Q213

R42100k

R5240

R4

10

C29

1000p

R541

1.5

k

R4747k

C211

0.1

u

2SC4116(GR)Q512

R12

10

C573

1000p

R261

10k

R512

470k

C587

1000p

L212

330n

C542

0.1

u

C540

47p

R218

L517

100n

2SC4116(GR)Q508

R2043.3k

R504

1k

C5541p

D5MA742

L519

82n

C40820p

R557

10k

XF201

Wide44.85MHz

L10

110n

R34

100

R9

22

R551

330

R565

330

R247

820

R41

0

D511

1S

V278

C244

0.0

1u

C254

220p

R22

150k

L518n

C191000p

C53

1000p

C553

1000p

C9

1000p

C279

27p

C26

1000p

Q202DTC114EE

C263

0.1

uR243

1k

R259

100

C560

47u

20

2SC4116(BL)Q504

C287

0.0

1u

C37820p

D502

1S

V282

R2376.8k

R5494.7k

C94

470u

25

C544

1000p

R272

4.7

k

C33

1000p

C229

0.0

1u

R223

22

C209

270p

R211

3.3

k

C205

1000p

C206

1500p

C207

0.1

u

C210

1000p

D102

02D

Z18(X

,Y)

R51110k

R505

10

R519

10R517

10

C516

1000p

C520

0.2

2u

C545

1000p

R535

1k

C523

0.1

u

C201

0.2

2u

C2610.01u

R2651k

CN203

E40-5538-05

12

C2711000p

R43

100k

R58

100k

C556

1p

R540

100

Q514DTC114EE

L210L208

C761

22p

R789

18k

C798 0.01u

R824

15k

R804

100k

IC714TC75W51FU

1 OUT-A

IN(-)-A

IN(+)-A

4

VSS

5

8

R819

56k

C80122u 6.3

R795

120k

R80247k

R828

10k

R815

47k

R820 33k

C764

1.5

u10

C779 100p

C809

47u

25C762

0.01u

R794

3.9k

D711MA742

Q709DTC144EE

C819

47u

25

C802

68p

R838

470k

R814

10k

R821

47k

R810

150k

2SD1757KQ711

C77022u 6.3

C790

0.0

1u

C784

39p

R798 0

IC712TA75W01FU

1OUT1

IN1-

IN1+

4VEE

5

8

R834

10k

C768

0.1u

C813

0.1

u

IC713AK4550VT

1 VCOM

AINR

AINL

VSS

VDD

DEMO

DEM1

8SDTO

9

16 IC721LMC7101BIM5

1OUTPUT

2V+

3 INPUT+ 4INPUT-

5V-

R797

56k

R803

270k

R785

220k

C797

0.0

1u

C814

0.0

1u

R799

10k

C772

10u

10

C8031200p

C766

150p

IC718M62364FP

1

1213VIN5

VOUT5

VOUT6

VIN6

DO

VDAref

24

R813

15k

R831

100k

R837

270k

2SC4116(Y)Q707

C823

100p

R826

10k

C815

0.1u

R786

680k

IC715TA75W01FU

1

4 5

8

R832

47k

R829

1k

C77110u10

R800

220k

C78122u 6.3

R816

47k

C777

0.1

u

C776

0.0

1u

C789 1000p

C810

1000p

C774

0.1

u

R811

100k

R823

220k

C796

1500p

R839 100k

R7931k

R808

82k

C820 0.01u

IC720TDA8561Q

1-I

NV

12

GN

D<

S>

3IN

V2

4R

R5

VP

I6

OU

T1

7G

ND

18

OU

T2

9N

C10

OU

T3

11

GN

D2

12

OU

T4

13

VP

214

MO

DE

15

INV

316

VD

IAG

17

-IN

V4

C769

0.1u

C799 0.01u

C793

33p

C775

0.0

1u

C773

47p

C800 22u 6.3

C811

100p

2SA1586(Y,GR)Q708

C822

0.1u

R784

680

R841

100k

R817

100k

C765

1.5

u10

R818

100k

R83639k

C817 0.01u

C767

10u

10

C778

10u

10

IC716TA75W01FU

1

4 5

8

R835

100k

R812

100k

C780 100p

C806 0.01u

C78810u 10

C808

10u

10

C816

0.1u

IC717BU4053BCFV

1Y1

Y0

Z1

Z

Z0

INH

VEE

8VSS

9C

B

A

X0

X1

X

Y

16VDD

R788

68k

IC2TA75W01FU

1

2

3

45

6

7

8

TC

501

8p

IC501

AD

F4111B

RU18

9D

GN

D

CE

CLK

DATA

LE

MU

XO

UT

DV

DD

16

VP

D712MA742

D513HVC131

D514HVC131

C305

0.1

u

TH

1

S1R

104J475H

VR

700

R32-0

643-0

5

IC202TC7S66FU

1

2

34CONT

5VCC

C30622u6.3

R28768k

R286220k

R510100k

R568100k

2SA1832(GR)Q518

C593

0.0

68u

Q519DTC144EE

R569

10k

C594

1000p

$IC109AN8009M

2

COM

3IN

1OUT

Q104DTC114EE

Q105

DTC114EE

IC104 TA7808S

3

GND

1IN

2OUT

IC105TA7805F

3

GND

1IN

2OUT

IC106XC62FP3302P

1

VSS

2 VIN 3VOUT

IC107XC62FP1802P

1

VSS

2 VIN 3VOUT

IC108XC62FP3302P

1

VSS

2 VIN 3VOUT

IC101

PS

T9140N

R

1N

C2

VE

E1

3V

EE

24

OU

T

5V

CC

IC103PST9140NR

1N

C2

VE

E1

3V

EE

24

OU

T

5V

CC

Q101DTC114EE

Q102DTC114EE

Q108DTA114EE

Q111DTA114EE

Q109DTA114YE

Q112DTA114YE

Q113DTC114YE

Q110DTC114TE

IC102

TC

4013B

F(N

)

1Q

12

Q1

3C

LK

14

R1

5D

16

S1

7V

SS

8S

2

9D

2

10

R2

11

CLK

2

12

Q2

13

Q2

14

VD

D

D104

1S

S355

D106

1S

S355

D105

1S

S355

R112

1k

R120

10k

R121

33k

R115

100k

R114

47k

R113

100k

R123

1k

R11710k

R118

100k

R119

1k

R125

47k

R124

33k

C105

0.0

47u

C106

0.0

47u

C112

0.1

u

D103

02D

Z15(X

,Y)

D10902DZ10(Z)

C108

4.7

u20

C135

10u

10

D108DA204U

C134 0.22u

R116

47k

C77

22p

C80

1000p

C832 100p

L206

C90

30p

R21

100

R844

47k

C833

0.1u

Q714DTC144EE

C834 0.01u

R847

120k

R848 330k

C835 47p

R849

1k

L508

2.7

u

L5052.7u

L516

2.7

u

L507

3.3

u

L5043.3u

L515

3.3

u

L514

2.7

u

R572

2.7

k

2SC4116(GR)Q520

C584

4.7

u10

D515

MA

2S

111

R571

10k

Q521DTC144EE

R570

100k

D714

1S

S388

R122

4.7k

R82547k

C826

1000p

C807

0.0

1u

C827

1000p

C828

1000p

C825

1000p

C829

1000p

Q710DTC114EE

CN704E40-3241-05

1

2

3

4

5

6

R827

0

C220

0.0

1u

C217

0.0

1u

R284

220

R285

220

R276

0

C216

0.0

33u

Q205DTA144EE

R21722k

IC722TA75S01F

1IN(+)

2VEE

3IN(-)

4OUT

5VCC

CF204CF202

Narrow

D512

02D

Z12(Y

)

CF201Wide

CF203

R822

1k

2SC4116(GR)Q517

C580

1000p

C576

22u

10

C579

47u

10

C581

0.0

1u

C574

0.0

1u

R561

1.5

k

C571

1000p

R56010

X501L77-1902-05

16.8MHz

VC

GN

DO

UT

PU

T

+D

C

2SC3357Q2

IC719TC75W51FU

1 OUT-A

IN(-)-A

IN(+)-A

4

VSS

5

8

C760

470p

CN703

E40-5176-05

1

2

3

4

5

6

7

8

9

10

11

R560

2SC3356(R24)Q1

C237

100p

C240

1000p

L16

56n

L17

56n

C1527p

R200

56k

D111SS355

C24

820p

R506

0

R573

10k

F100F53-0278

-05

IC723NJM78L05UA

2

COM

3IN

1OUT

C836

10u

10

C837

0.1

u

C838

0.1

u

R126

0

R218

1k

C200

0.1

u

R853

100k

C787

1000p

Q7122SJ243

S

DG

R854

470k

D786 02DZ5.1(Y)

D78502DZ5.1(Y)

D788

02D

Z5.1

(Y)

D787

02D

Z5.1

(Y)D789

02D

Z5.1

(Y)

D790

02D

Z5.1

(Y)

TP

TP

TP

L7

2.5n

R2890

R46

47k

C63

0.2

2u

C46

33p

C44

39p

C50

27p

C35

36p

R864

10k

R865

10k

C794

10u

10

C795

22u

6.3

TH

2S

1R

104J475H

C30

1000p

C92

47u

20

C812

100u

25

R271

47kTH202

157-104-65001

R288

150k

C782

22u 6.3

C80522u 6.3

C785

22u

6.3

R59

0

2SC5108(Y)Q513

RD70HVF-01Q5

RD55003SQ4

BCLKR0

BCLKR1

BFSR0

BDR0

BDX0

XF

DT

CK

LD

AM

D791

MINISMDM075/24

TXD

RXD

IGN

CV

TP

D209 1SV228

L201

R5151.5k 0.5

C2705p

C65

1000p

L713

L92-0140-05

IC724TC4W53FU

1

COMMON

2

3

45A

6ch1

7 ch08

VDD

R866

0

R859

33k

R868

0

R867

0

R858

47k

C844

1000p

RS

ET

CP

CP

GN

D

AG

ND

RF

INB

RF

INA

AV

DD

RE

FIN

IN/OUT

OUT/IN

GND

CP

DT

EP

OS

CIN

OS

CO

UT

MIX

OU

T

VC

C

IFIN

DE

C

FIL

OU

T

FIL

IN

IN2+

IN2-

OUT-B

VCC

SDTI

LRCK

MCLK

SCLK

PWAD

PWDA

AOUTL

AOUTR

IN(+)-B

IN(-)-B

OUT-B

VDD

IN2+

IN2-

OUT-B

VCCOUT1

IN1-

IN1+

VEE

INH

VEE

VSS

IN(+)-B

IN(-)-B

OUT-B

VDD

IN2+

IN2-

OUT-B

VCCOUT1

IN1-

IN1+

VEE

VIN1VOUT1

VOUT2

VIN2

VDD

LD

CLK

DI

VIN3VOUT3

VOUT4

VIN4

RESET

GND

VIN7

VOUT7

VOUT8

VIN8

OUT1

IN1-

IN1+

VEEIN2+

IN2-

OUT-B

VCC

IC1TA75W01FU

5IN2+

6

7

8 8C1OUT1

2IN1-

3IN1+

4VEE

IN2-

OUT-B

VCC

R20

56kR18

100k

Note : Components marked with a dot (•) are parts of layer 1.

TK-7150 TK-7150

64

BLOCK DIAGRAM

4.9152MHz

PC

TV

APC

MA4PH633XB15A709

2SC3357

Mixer

2SK508NV(K52)x4

2SC3357

2SC3357

HVC131

TA75W01FU

1SV228

RD70HVF1PD55003S

12.0dBPout= 48.5dBmIdø=1.5A

19.0dBIdø=150mA36dBm

17.0dBm 17.0dBm

10.0dBIdø=10mA10dBm±2dB

50Ω 50Ω 50Ω

50Ω

BATT

TA31136FN

DET

AMP

12CL

MI2

MUTE

Mic Sens(VR700) TC75W51FU

2SA1586(Y,GR)2SC4116(Y)

SB

AVR8V

8R

8T

PROTECT

PROTECT

8C

+B

SB

8CL

AVR5V

AVR3.3V

AVR3.3V

AVR1.8V

SW

SW

8TC

8RC

5C

3.3A

3.3D

1.8D

AVRVoltageDoubler

BCLKR1(4.9152MHz)

C

DSA3A1-FK

ZSA5A27

2SJ506(S)

TA7805F XC62FP3302P

XC62FP3302P

XC62FP1802P

MB

PLL

455kHz

16.8MHz

5C UL

MOVCO

VCO

INV

SW

SW

SWSWVCXO

8CL

STR

8CL

STR

FM IC

DAN235E DAN235E

2SC5108(Y)

2SC4116(BL)x3

2SC4116(GR)

2SC4116(GR)

2SC5108(Y)2SK508NV(K52), 1SV282x4

DAC

MO

MB

FC

AAM

AF AMPTDA8561Q

M62364FP

TA75W01FU

TA75W01FU

LMC7101BIM5

AFO

STONE(ANI)

BU4053BCFV

DISPLAY UNIT (X54-340)

AVR

BUSYLED

(D915)

KEY x 6

DMHK/RXD

PTT/TXD

RST

RXDTXD

IC904µCom

30622M4A-443GP

12MHz

SW

KEY BackLight(D908,909,910,911,913,914)

SW

8.5V

TXLED

(D912)SW

8.5V

5V

VOL

IRSES2

POWER SW

PSW

BLC

TX

RSSIW/N

RS232DRIVER

TXD2,RXD2TXD3,RXD3

TXO(SCR)

CODEC

AK4550VT

320VC5402PGE

µCom

ADM202EARN

DSP

30620M8A-5H1GP

PROTECT

SW

IGNSENS

02DZ18(X,Y)DTC114EE

SW

VoltageDETECTOR

PST9140NR

TC4013BF(N)

PSW

IGN

RST5C

RIPPLEFILTER

RIPPLEFILTER

TA7808S

2SB1132(Q,R)

2SB1132(Q,R)

2SC4116(GR)

2SC4116(GR)

2SA1832(GR)2SC4738(GR)1SS388x2 2SC4116(GR)

02DZ12(Y)

2SK1215(E)

ADF4111BRU

12CL

8CL

5C

3mΩ/1W

+B

Fin=0dBm±5dB

SWSW

2SC4215(Y)DAN235E DAN235E

180.85~218.85MHz+15dBm

44.85MHz–117.0~–118.0dBm

136~174MHz–117.0~–118.5dBm

1A Max2W Max

1A Max1W Max

0.5A Max0.5W Max

0.5A Max0.5W Max

0.5A Max0.5W Max

SW

LCDAssy

AVR

BEATSHIFT

8.5VDTC114EE

DTC114EE

DTC114EE

DTC114EE

5V, 8.5V

CH SW(S1)

2SK1824

BU4053BCFV

2SJ243

TA7805F

2SD176002CZ9.1(X,Y)

5V

VOL(VR901)

8.5V

VDD

DMHK/RXDPTT/TXD

INT.SP

BLC

BLC3BLC4

PF1~PF6

BUSY

BLC2

CL,CE,DI,DO

P1,P2,P3,P4

SFT

TXI(SCR)DATA(ANI)

INV

5C DETO(ANI)

PWADPWDA

DATA

1.8D3.3D

SCLK

LRCK

MCLK

19.2kHz

614kHz

SDTISDTO

SUM

BDX0BDR0

19.2kHz:BFSR0614kHz:BCLKR04.9152MHz:BCLKR1

XF

HD0~HD7

INT0

RS

HCSHRWHBILHCNTL0HCNTL1

Flash ROM

AT29C040A-12TI

A0~A3A4~A18CE,OE,WE D0~D7

Interface Interface

SCL SDA

EEPROMAT24128N10SI27

DIRD0~D7

3.3D

5MD5C3.3D

5MD

5C

5C

DTC144EE

MA2S111

TC7WH32FKx3 TC74LVX4245FS

5MD

INV

12.288MHz

1.8D

TXDRXD

BEATSHIFT 12.288MHz

RST

POF

5C

5C

5C

AI1~AI4

AUX(ANI),MCM(ANI)TCNT(ANI),KEY(ANI)

DT,CK,EP,CP,OELD,STB1,STB2

8RC,8TC,STRW/N,AM

TEMP1,TEMP2ASQ,RSSI,UL

5C

RXO(SCR)

AFO

RXI(SCR)

DI

B

ES1

ES2

OS1

OS2

2SD1757K BU4053BCFV

8C

5C

VDD

VRef

PC

TV

5C

MCO

RST

5CDT,CK,LD

DTCK,OESTB1

A,B,C,HRAO1~AO4

BU4094BCFV

5C

SHIFT

SHIFT

5C

BU4094BCFV

DTCK

STB2

PTO,EMG,BUSY(ANI)

AC,BC1~4(SCR)

TX

D3

RX

D3

EA

I213A

FOE

AI3

ME

SB

TX

SH

R1

DE

OA

O1

AI1

AO

4H

R2

RX

D2

TX

D2

AO

3D

IM

I2E

AO

2A

I4

AC

C D

-Su

b 2

5pin

SurgeProtect

SW

SurgeProtect

AI1~AI4

DA204U

DA204U

DTD114EK

AO1~AO4

TXD2,RXD2TXD3,RXD3

AFODEO

MI2

DI

SBHR2HR1

HR

ACC 6pin

2SC5108(Y)

8C

12~13dB

0.1A Max0.35W Min

3A Max1W Min

5C

3.3A15mA Max

8C

8C

8C

SB

SFT

2SK1824

50mA/1uAMax35mA Typ

40mA Max0.1mA 3mA/

18µA Max

35in40mA

–121.5~–122.0dBm–118.0~–120.0dBm

–111.5~–113.0dBm

IGN

POF

D101

D1

D102,Q102

R827

IC103

IC102

Q103

IC104Q517

IC105 IC106

Q106 IC108

Q107 IC107

Q508,D512 Q511

Q502

Q505,Q506,D509,D510

Q902Q901

IC901

Q903,D907

Q905

Q906

Q907

Q904,Q908

ATT

IC714Q707,Q708

MA742D711,D712

R798

TC75W51FUIC719

IC717

5C

AVR

IC718

IC719 IC723TC75W51FU NJM78L05UA

IC715

IC715

IC721

TA75S01FIC722 Q711 IC717

IC720

5C

D209D208D2071SV2281SV228

SW

IC724TC4W53FU

5C BS

Q213Q209~Q212

Q208

D513,D514

Q207

5C

W/NW/N

D206D205Q206

D203D204

W/NW/N

IC201

Q205DTA144EE

DETSQL

Q204 2SC4617(S)

MA742D202

IC713

8R8R8R

8R

Noise AMP

IC501

Q513

Q515

Q516

Q514DTC114EE

Q501,Q503,Q504

Q510

Q512

Q509,D502,504,507,508

Q507,D501,503,505,506,D5112SK508NV(K52), 1SV282x4, 1SV278

R16

ATT

Q1 Q22SC3356(R24) 2SC3357

Q4 Q5

IC2

D3,D47.0dBIdø=15mA17dBm

8T 8T

DET

D5,6MA742

D703,705,706,709

Q703,704,705,706

D701,702,707,708

TXS

K700

IC701

PTO

Q700

IC707,708,709IC705 IC706 IC704

IC703

Q702

D704

INV

IC711TC7SU04FU

IC710

IC717

5C

Q709DTC144EE

IC702

IC700

R781

SW8TC

DTC114EEQ716

SW SW

Q518,5192SA1832(GR)DTC144EE

Q520,521,D5152SC4116(GR)DTC144EEMA2S111

EPCPDT

8T

44.395MHz

SW

IC712TA75W01FU5C

8RC

IC202TC7S66FU

CLOCK

IC716TA75W01FU

MCOIC712TA75W01FU

SWIGN

PSW

5MD

5MD Q7132SK1824

Q710DTC114EE

SW

Q701DTC114EE

DETO

5C

IC714TC75W51FU

RESET

NC

25

1

14

IC716TA75W01FU

REGISTER

REGISTER

R866

SW

RF AMP

Buff AMP

Front AMP

Local AMP

IF AMPRF AMP

3 6 6

2 55

1 4

IGN

ES2ES1IRS

OS1OS2

TK

-715065

WIRIN

G

IRSES1ES2OS1OS2IGN

1

6

+B

GND

CN102

NC

RXD2

TXD2

MI2

AO3

E

DI

RXD3

AI4

SB

AO2

E

AI2

TXS

TXD3

HR1

AFO

E

AI1

DEO

AO1

AO4

ME

HR2

AI3

J700

1BUSYEMG

AUXKEY

INH

E

TCNTSTON

8C

DATA

PTOADETONCNC14

CN700

NC

RXI

14

BC2

TXI

8C

BC3

1

RXOPTOS

NC

CN701

AC

TXO

BC4

E

BC1

IRS

E

11

RXD

ME

E

1

ES2

SB

CN703

RESET

MIC

PSW

TXD

PSW

ES2IRS

RESET

MIC

1

RXDE

TXD

SB

ME

E

11

CN902

CN

90615LE

DA

NC

CL

VC

C

1DO

DIS

P

DI

LED

K

ECE

10

CN

905

1

2

IRS

ES2

INT SP

CN901

HK

SBBLC

DM

E

ME

8

MIC

PTT

1

ANT

J901

TX-RX UNITX57-6570-10

DISPLAY UNITX54-3400-10 A/2

13.6V

+

–

1 5

2 3 5 6 1 4

P3

EP1

P4

P2

W1

R59

CN7046

1 4

3

6

5

13

114

25

15263748

Channel SwitchX54-3400-10 B/2LCD ASSY

B38-0875-05

+

–

TK-7150

66

TERMINAL FUNCTION

1. Display Unit (X54-3400-10) (A/2)

Pin No. Name Description

CN901 (To remote speaker)

1 IRS BTL output for remote speaker output.

2 ES2 BTL output for remote speaker output.

CN902 (To TX-RX unit)

1 ME MIC ground.

2 MIC MIC signal output.

3 E Ground.

4 RESET Reset signal input.

5 TXD Serial data input.

6 RXD Serial data output.

7 E Ground.

8 PSW Power switch control signal output.

9 SB Power input after power switch (13.6V±15%).

10 IRS BTL input for remote speaker output.

11 ES2 BTL input for remote speaker output.

CN905 (To LCD assy)

1 E Ground.

2 VCC 5V.

3 CE Enable output for LCD driver.

4 CL Clock output for LCD driver.

5 DI Data output for LCD driver.

6 DO Not used.

7 DISP Display control signal output. “L” : Display off

8 LEDA Power output for LCD backlight.

9 LEDK Ground for LCD backlight. “L” : Backlight on

10 NC Non connection.

CN906 (To Display unit B/2 : CH SW)

1 E Ground.

2 P4 SW position signal input 4.




J901 (MIC jack)

1 DM Serial data input for keypad MIC.

2 MIC MIC signal input.

3 PTT PTT signal input. “L” : TX, “OPEN” : RX

Serial data output.

4 SB Power output after power switch (13.6V±15%).


5 HK Hook signal input. “L” : On hook, “H” : Off hook

Serial data input.

6 ME MIC ground.

7 E Ground.

8 BLC MIC backlight control signal output. “H” : On, “L” : Off

2. Display Unit (X54-3400-10) (B/2)


W1 (To Display unit A/2)

1 P1 SW position signal output 1.




5 E Ground.

3. TX-RX Unit (X57-6570-10)


CN700 (To ANI board)

1 BUSY

2 EMG Emergency signal output.

“L” : Emergency function is operated,

“H” : Emergency function is not operated

L ≤ 0.05V, H ≥ 4.6V/30kΩ load

3 KEY TX control signal input.

Active low with 47kΩ pull-up to 5V

L ≤ 0.8V, H ≥ 2.5V

4 AUX Emergency signal input.


L ≤ 0.8V, H ≥ 2.5V

5 INH MIC mute signal input. “L” : Mute


L ≤ 0.8V, H ≥ 2.5V

6 STON Side tone input.

7 TCNT Speaker mute signal input. “L” : Unmute

L ≤ 0.8V, H ≥ 2.5V

8 DATA Data signal input.

9 E Ground.

10 8C 8V. (CN700 No.10 + CN701 No.13 = 100mA Max.)

TX sens signal output.Conventional “H” : Not TX, “L” : TXLTR “H” : Not Link complete, “L” : Link complete

TK-7150

67

TERMINAL FUNCTION


11 PTOA PTT signal output. “L” : PTT on, “H” : PTT off

L ≤ 0.05V, H ≥ 4.6V/30kΩ load

12 DETO Detected signal output. DC coupled. Zo ≤ 100Ω

Wide : 0.8Vp-p typ., Narrow : 0.7Vp-p typ.

(Standard modulation)



CN701 (To voice scrambler)

1 TXI MIC signal input (Capacitor-coupled). Zin = 100kΩ

2 TXO MIC signal output (Capacitor-coupled). Zo = 1kΩ

Wide : 85mVp-p typ., Narrow : 85mVp-p typ.


3 RXI Audio signal input (Capacitor-coupled). Zin = 27kΩ



4 AC Scrambler control signal output. “L” : On, “H” : Off

L ≤ 0.05V, H ≥ 4.6V/30kΩ load

5 BC1 Scrambler code signal output 1.

L ≤ 0.05V, H ≥ 4.6V/30kΩ load


L ≤ 0.05V, H ≥ 4.6V/30kΩ load


L ≤ 0.05V, H ≥ 4.6V/30kΩ load


L ≤ 0.05V, H ≥ 4.6V/30kΩ load



11 RXO Audio signal output. DC coupled. Zo ≤ 100Ω



12 PTOS TX signal output. “L” : TX, “H” : Not TX

L ≤ 0.05V, H ≥ 4.6V/30kΩ load

13 8C 8V. (CN700 No.10 + CN701 No.13 = 100mA Max.)

14 E Ground.

CN703 (To Display unit A/2)

1 ME MIC ground.

2 MIC MIC signal input.

3 E Ground.

4 RESET Reset signal output.

5 TXD Serial data output.


6 RXD Serial data input.

7 E Ground.

8 PSW Power switch control signal input.

9 SB Power output after power switch (13.6V±15%).

10 IRS BTL output for remote speaker output.

11 ES2 BTL output for remote speaker output.

CN704 (To ACC 6-pin connector)

1 IRS Remote speaker switch.

2 ES1 BTL output for external speaker A.


4 OS1 BTL output for external speaker B (PA).


6 IGN Ignition sense input.

J700 (ACC 25-pin)


2 RXD2 * Serial data input 2. RS-232C level. Input voltage

range = ±30V max. L ≤ 0.4V, H ≥ 2.4V. Zi ≥ 5kΩ

3 TXD2 * Serial data output 2. RS-232C level.

L ≤ –5V, H ≥ 5V/3kΩ load. Zo ≤ 2kΩ

4 AO3 Auxiliary output 3 (Programmable). Active low

open collector (100mA max.) (Default none).

L ≤ 0.3V

5 DI Data signal input (Capacitor-coupled).

6 MI2 External MIC input (Capacitor-coupled).

7 E Ground.


with 10kΩ pull-up to 5V (100mA max.) (Default

none). L ≤ 0.3V, H ≥ 4.8V

9 TXD3 ** Serial data output 3.

L ≤ 0.7V, H ≥ 4.2V/25kΩ load. Zo ≤ 1kΩ

10 RXD3 ** Serial data input 3.

Input voltage range = +5/0 max. L ≤ 0.8V, H ≥ 4.2V.

11 E Ground.

12 AI4 Auxiliary input 4 (Programmable). Active low

with 47kΩ pull-up to 5V (Default none).

L ≤ 0.8V, H ≥ 2.5V



L ≤ 0.8V, H ≥ 2.5V

TK-7150

68


14 SB Power output after power switch. 13.6V±15%,

1.1A max. at 25°C, 0.8A max. at 60°C

15 TXS TX sense signal output. Active high with 10kΩ

pull-up to 5V. L ≤ 0.3V, H ≥ 4.8V

16 HR1 Horn alert signal output 1. 1A max.

17 AFO Filtered audio output (DC coupled). Zo ≤1kΩ

PA : MIC signal output. 0.65Vp-p typ. (1kHz/5mV input)

RX : RX low level output. Wide : 1.3Vp-p typ.,

Narrow : 1.1Vp-p typ. (Standard modulation)

18 E Ground.

19 DEO Detected signal output (Capacitor-coupled).


with 10kΩ pull-up to 5V (100mA max.) (Default

none). L ≤ 0.3V, H ≥ 4.8V



L ≤ 0.8V, H ≥ 2.5V


open collector (100mA max.) (Default none).

L ≤ 0.3V

23 HR2 Horn alert signal output 2. 1A max. (Default ground)



L ≤ 0.8V, H ≥ 2.5V

25 ME MIC ground.

* and ** : Pair

4. ACC 6-pin Connector


1 IGN Ignition sense input.





6 RS1 Remote speaker switch.

13121110987654321

2019181716 25242322211514

TERMINAL FUNCTION / OPTIONS

41

52

63

1. KES-5 (External Speaker)

1-1. External View

2. KRK-9 (Single Control Head Remote Kit)

1-1. External View

1-2. Parts List

Ref. No. Parts No. DescriptionNewparts

A62-1050-08 Panel assy A82-0050-08 Rear panel

B43-1142-08 Badge Panel

E30-3479-08 Speaker cable

G13-1923-08 Cushion SP front G53-1553-08 Packing Rear panel

J29-0699-08 Bracket

N08-0551-08 Dressed screw Bracket N99-2031-08 Screw set Acc

T07-0741-08 Speaker

: New parts

1-2. Parts List

Ref. No. Parts No. DescriptionNewparts

A62-1039-02 Panel Body A82-0049-02 Rear panel Head

E37-1008-05 Lead wire with connector 11P

F07-1865-03 Mold cover For cable

G02-0895-04 Earth spring Cable GND G53-1552-03 Packing Rear panel

J21-8447-04 Hardware fixture Panel J29-0698-03 Bracket Acc

N08-0550-04 Dressed screw AccN87-3008-45 Brazier head taptite screw Panel

N99-2032-05 Screw set Acc

: New parts

TK-7150

69

SPECIFICATIONS

GENERAL

Frequency Range ............................................ 136~174MHz (K)Number of Channels (Zone) ............................ Conventional CH : Max.128 (1 zone x 128ch~128 zones x 1ch)

Trunking ID : Max. 250/zone (max. 32 zones)Channel Spacing.............................................. Wide : 25kHz, 30kHz Narrow : 12.5kHz, 15kHzOperating Voltage ........................................... 13.6V DC±15%Current Drain ................................................... Standby : 0.5A Receive : 2.3A Transmit : Less than 12ADuty Cycle ....................................................... Transmit : 20%Operating Temperature range ......................... –22ºF~+140ºF (–30ºC~+60ºC)Frequency Stability (–22ºF~+140ºF) ................ ±0.00025%Antenna Impedance ........................................ 50ΩDimensions (W x H x D) .................................. 7-1/12” x 2” x 7” (180mm x 50mm x 170mm)Weight (net) .................................................... 5.9 lbs (2.7kg)Band Spread .................................................... 38MHz

RECEIVER

Sensitivity ........................................................ 12dB SINAD : 0.35µV 20dB Quieting : 0.45µVSelectivity ........................................................ Wide : 84dB (±30kHz) Narrow : 76dB (±15kHz), 76dB (±12.5kHz)Intermodulation ............................................... Wide : 77dB (±30, 60kHz) Narrow : 75dB (±15, 30kHz)Spurious Response ......................................... 85dBExternal Audio Output ..................................... 12W (@4Ω 3% distortion), 13W (@4Ω 5% distortion)Internal Audio Output ...................................... 3.2W (@16Ω 3% distortion), 3.5W (@16Ω 5% distortion)

TRANSMITTER

RF Output Power ............................................ 50 to 15 watts High : 50 watts Low : 15 wattsType of Emission............................................. Wide : 16K0F3E, 20K0F1D Narrow : 11K0F3E, 11K2F1DSpurious Response ......................................... 75dBFM Hum & Noise ............................................ Wide : 48dB Narrow : 42dBMicrophone Impedance .................................. 600ΩAudio Distortion .............................................. Less than 1% at 1000Hz

Kenwood follows a policy of continuous advancement in development.For this reason specifications may be changed without notice.FleetSync™ is a trademark of Kenwood Corporation.

Applicable MIL-STD

Standard MIL 810C MIL 810D MIL 810E MIL 810F

Methods/Procedures Methods/Procedures Methods/Procedures Methods/Procedures

Low Pressure 500.1/Procedure I 500.2/Procedure I, II 500.3/Procedure I, II 500.4/Procedure I, IIHigh Temperature 501.1/Procedure I, II 501.2/Procedure I, II Cat. A1 501.3/Procedure I, II Cat. A1 501.4/Procedure I, IILow Temperature 502.1/Procedure I 502.2/Procedure I, II Cat. C1 502.3/Procedure I, II Cat. C1 502.4/Procedure I, IITemperature Shock 503.1/Procedure I 503.2/Procedure I Cat. A1,C1 503.3/Procedure I Cat. A1,C1 503.4/Procedure I, IISolar Radiation 505.1/Procedure I 505.2/Procedure I 505.3/Procedure I 505.4/Procedure IRain 506.1/Procedure II 506.2/Procedure II 506.3/Procedure II 506.4/Procedure IIIHumidity 507.1/Procedure II 507.2/Procedure II 507.3/Procedure II 507.4Salt Fog 509.1/Procedure I 509.2/Procedure I 509.3/Procedure I 509.4Dust 510.1/Procedure I 510.2/Procedure I 510.3/Procedure I 510.4/Procedure I, IIIVibration 514.2/Procedure VIII, X 514.3/Procedure I Cat. 8 514.4/Procedure I Cat. 8 514.5/Procedure I Cat. 20Shock 516.2/Procedure I, II, III, V 516.3/Procedure I, IV, V 516.4/Procedure I, IV, V 516.5/Procedure I, IV, V

KENWOOD CORPORATION2967-3, Ishikawa-machi, Hachioji-shi, Tokyo 192-8525, Japan

KENWOOD SERVICE CORPORATIONP.O. BOX 22745, 2201 East Dominguez Street, Long Beach, CA 90801-5745, U.S.A.

KENWOOD ELECTRONICS CANADA INC.6070 Kestrel Road, Mississauga, Ontario, Canada L5T 1S8

KENWOOD ELECTRONICS DEUTSCHLAND GMBHRembrücker Str. 15, 63150 Heusenstamm, Germany

KENWOOD ELECTRONICS BELGIUM N.V.Leuvensesteenweg 248 J, 1800 Vilvoorde, Belgium

KENWOOD ELECTRONICS FRANCE S.A.13, Boulevard Ney, 75018 Paris, France

KENWOOD ELECTRONICS U.K. LIMITEDKENWOOD House, Dwight Road, Watford, Herts., WD18 9EB United Kingdom

KENWOOD ELECTRONICS EUROPE B.V.Amsterdamseweg 37, 1422 AC Uithoorn, The Netherlands

KENWOOD ELECTRONICS ITALIA S.p.A.Via G. Sirtori, 7/9 20129 Milano, Italy

KENWOOD IBERICA S.A.Bolivia, 239-08020 Barcelona, Spain

KENWOOD ELECTRONICS AUSTRALIA PTY. LTD.(A.C.N. 001 499 074)16 Giffnock Avenue, Centrecourt Estate, North Ryde, N.S.W. 2113 Australia

KENWOOD ELECTRONICS (HONG KONG) LTD.Unit 3712-3724, Level 37, Tower one Metroplaza, 223 Hing Fong Road, Kwai Fong, N.T., Hong Kong

KENWOOD ELECTRONICS TECHNOLOGIES(S) PTE LTD.Sales Marketing Division1 Ang Mo Kio Street 63, Singapore 569110

TK-7150

Documents

SERVICE MANUAL - Fracassi · TK-7150 3 5-2. Radio location Select a convenient location for your control station radio which is as close as practical to the antenna cable entry point