Upload
others
View
3
Download
0
Embed Size (px)
Citation preview
31.5 &42 LCD TV Haier HL32D2&HL42XD2
1
ServiceServiceService
Horizontal Frequency 31~68 KHz
Table of Contents
Description Page Description Page
SAFETY NOTICE
ANY PERSON ATTEMPTING TO SERVICE THIS CHASSIS MUST FAMILIARIZE HIMSELF WITH THE CHASSIS
AND BE AWARE OF THE NECESSARY SAFETY PRECAUTIONS TO BE USED WHEN SERVICING
ELECTRONIC EQUIPMENT CONTAINING HIGH VOLTAGES.
CAUTION: USE A SEPARATE ISOLATION TRANSFOMER FOR THIS UNIT WHEN SERVICING
6.1 Main Board………………..………………...……….....30
6.2 Power Board…..…………..……….…….…..…..........34
6.3 Key Board…………………………..……..……….......40
6.4 IR Board……………………………..……….…….......40
7.Adjustment..............................................................41
8.Block Diagram.…….....................................................42
9.Wiring Diagram.……....................................................43
10.Schematic Diagram….....……..……..………………...45
10.1 Main Board…….………...….………………...….......45
10.2 Power Board…….……….…....………...……….......58
10.3 Key Board………….……...….……….………….......67
10.4 IR Board……………..……..…………….……….......68
11.Exploded View……………………….………….…....69
Table of Contents.......……...................................…........1
Important Safety Notice......................................……......2
Revision List…………………………………………………3
1.General Specification.................................……........4
2.Operating Instructions…………………….……..….......6
2.1 The Use of Remote Control…….…………...…….......6
2.2 To Use the Menus…...………………….….………......7
2.3 Front Panel Control Knobs……………….………......12
2.4 How to Connect…….…………………….…..…….....13
3.Input/Output Specification…………....................…....14
4.Mechanical Instructions…………………….................17
5.Repair Flow Chart ……………………….…….…….....25
6.PCB Layout ………………..………………....…..........30
2
Important Safety NoticeProper service and repair is important to the safe, reliable operation of all Haier Company Equipment. The service procedures recommended by Haier and described in this service manual are effective methods of performing service operations. Some of these service operations require the use of tools specially designed for the purpose. The special tools should be used when and as recommended.
It is important to note that this manual contains various CAUTIONS and NOTICES which should be carefully read in order to minimize the risk of personal injury to service personnel. The possibility exists that improper service methods may damage the equipment. It is also important to understand that these CAUTIONS and NOTICES ARE NOT EXHAUSTIVE. Haier could not possibly know, evaluate and advise the service trade of all conceivable ways in which service might be done or of the possible hazardous consequences of each way. Consequently, Haier has not undertaken any such broad evaluation. Accordingly, a servicer who uses a service procedure or tool which is not recommended by Haier must first satisfy himself thoroughly that neither his safety nor the safe operation of the equipment will be jeopardized by the service method selected. Hereafter throughout this manual, Haier Company will be referred to as Haier.
WARNING Use of substitute replacement parts, which do not have the same, specified safety characteristics might create shock, fire, or other hazards.
Under no circumstances should the original design be modified or altered without written permission from Haier. Haier assumes no liability, express or implied, arising out of any unauthorized modification of design. Servicer assumes all liability.
FOR PRODUCTS CONTAINING LASER: DANGER-Invisible laser radiations when open AVOID DIRECT EXPOSURE TO BEAM. CAUTION-Use of controls or adjustments or performance of procedures other than those specified herein may result in hazardous radiation exposure. CAUTION -The use of optical instruments with this product will increase eye hazard.
TO ENSURE THE CONTINUED RELIABILITY OF THIS PRODUCT, USE ONLY ORIGINAL MANUFACTURER'S REPLACEMENT PARTS, WHICH ARE LISTED WITH THEIR PART NUMBERS IN THE PARTS LIST SECTION OF THIS SERVICE MANUAL. Take care during handling the LCD module with backlight unit -Must mount the module using mounting holes arranged in four corners. -Do not press on the panel, edge of the frame strongly or electric shock as this will result in damage to the screen. -Do not scratch or press on the panel with any sharp objects, such as pencil or pen as this may result in damage to the panel. -Protect the module from the ESD as it may damage the electronic circuit (C-MOS). -Make certain that treatment person’s body is grounded through wristband. -Do not leave the module in high temperature and in areas of high humidity for a long time. -Avoid contact with water as it may a short circuit within the module. -If the surface of panel becomes dirty, please wipe it off with a soft material. (Cleaning with a dirty or rough cloth may damage the panel.)
3
Revision List
Version Release Date Revision Instructions Customer Model Model
A00 Mar.29,2010 Initial release
HL32D2 E32AAZNK3WH3N
E32AAZNK3WH3XNX
HL42XD2 E42AMZNK3WH3N
E42AMZNK3WH3XNX
4
1. General Specification * This model complies with the specifications listed below. * Designs and specifications are subject to change without notice. * These models may not be compatible with features and/or specifications that may be added in the future.
Model No. HL32D2 HL42XD2
DISPLAY
Viewable 31.5W" 42W"
Television System NTSC standard,ATSC standard (8-VSB, Clear-QAM)
Channel Coverage
VHF: 2 through 13 UHF: 14 through 69 Cable TV: Mild band (A - 8 through A - 1,A through I),
Super band (J through W), Hyper band (AA through ZZ,AAA, BBB), Ultra band (65 through 94, 100 through 125)
CONNECTIONS Tuner input (75 )AV IN: AV/S-Video and L/R audio input
PC IN:D-SUB and PC Audio (Headphone mini-jack) Supported scan rate: 640x480@60/72/75Hz,720x400@70Hz,
800x600@56/60/72/75Hz,1024x768@60/70/75Hz, 1280x720@60Hz,1280x768@60Hz 1360x768@60Hz:For HL19D2 / HL32D2 only.
1280x1024@60Hz,1440x900@60Hz,1680x1050@60Hz 1920x1080@60Hz: For HL24XD2 / HL42XD2 only.
Rear Connectors Recommended: For HL32D2: 1360x768 For HL42XD2: 1920x1080
Component Video and L/R Audio input Supported resolution: 480i,480p,720p,1080i,1080p
HDMI input Supported scan rates: 480i, 480p, 720p, 1080i, 1080p
AV/S-Video input SPDIF HDMI 1 HDMI 2 Audio out
AV/S-Video input SPDIF HDMI 1 HDMI 2 Audio out
Side Connectors AV IN 2 Earphone Output USB PORT
AV IN 2 Earphone Output USB PORT
5
Model No. HL32D2 HL42XD2
WEIGHT & DIMENSIOIN Dimensions 790.5 mm
569.1 mm 239.6 mm
1015.36 mm 703.03 mm 280.50 mm
with Stand (W x H x D) Dimensions 790.5 mm
526.8 mm 91.1 mm
1015.36 mm 654.67 mm 97.10 mm
without Stand (W x H x D)
Weight with Stand 12.5 Kg 20.5 Kg Weight without Stand and Base 10.6 Kg 17.6 Kg
WALL MOUNTING VESA-compatible wall bracket (W x H) 200 x 200 mm 400 x 200 mm
Screw type Metric 6 x 10 mm Metric 6 x 10 mm
POWER
Power Consumption 150W 250W
Standby <1W
Mains Power 120V~60Hz
Audio Power 10W + 10W 10W + 10W
Ambient Temperature 5°C - 35°C
PACKAGE CONTENTS TV unit x1 Base x1
Supplied Accessories
Screws x 4 (for 32” only) Power cord x 1 Remote control x1 (with two size AAA alkaline batteries) User manual x1
English FCC statement x1
Registration Card x1
6
2. Operating Instructions2.1 The Use of Remote Control
Power Press to power ON/OFF(standby) TV. (Note: 1. TV is never completely power off unless physically unplugged. 2. Press to turn on TV after the power on status, LED had changed to blue and stopped flashing.)
VideoPress repeatedly to choose S-Video/Composite source mode.
Comp Press to choose Component source mode.
PC/HDMIPress repeatedly to choose VGA or HDMI source mode.
TVPress to choose ATSC/NTSC TV source mode.
0 ~ 9 / – number Press to enter TV channel number to select channel (Press ‘-’ to choose the sub-channel).
PREV CH Press to display the previous channel.
SleepPress to set the preset time to switch the TV to standby mode automatically (off / 5 / 10 / 15/ 30 / 60 / 90 / 120 / 180 /240 mins).
Freeze Press to freeze the displayed picture.
MTS/SAPPress to activate the NTSC TV sounds, such as: Stereo, SAP or Mono tone, and languages of DTV.
Wide Press to choose the display aspect as: Normal, Zoom1, Wide, Zoom2, or HDMI PC mode.
Fav Press "Fav" to open or toggle channel item in Favorite Channel List.
Source Press repeatedly to choose the various input sources.
EPGPress to display the Electronic Program Guide.
CH+ / CH - Press + or - to browse through the TV channels.
MuteSwitch the sound ON/OFF.
InfoPress to show the information about the input source, TV channel, display resolution and current time.
VOL+ / VOL Press + or - to adjust the volume.
Menu Press to open or exit menu.
, , , , ENTER Press to adjust the various function items on the menu.
ExitPress to exit menu or OSD.
V-ChipPress to lock Parental Control temporarily. (After setting the restricted table of MPAA or TV Rating.)
Video Adj Provide video modes switching.
Audio Adj Provide audio modes switching.
C. C. Press repeatedly to change the closed caption type as CC On/CC Off/CC On With Mute.
7
2.2 To Use the Menus 1. Press the Menu button to display or close the main menu. 2. Use the Navigation Ring to move around to select, adjust or confirm an item in the OSD (On Screen Display) menu. Press the Menu button to enter the main OSD. Adjust the items including Video menu,Audio menu, Feature menu,Channel menu, and VGA menu. However, some function items in the menus may only be enabled in the particular source modes.
CHANNEL MENU The Channel menu in TV mode shows as below.
1. Tuning Band: Select TV source signal from the Air (antenna) or Cable (CATV). 2. Channel Strength: Show the intensity of the received DTV signal. 3. Auto CH Search: Automatically scan all NTSC / ATSC TV channels and then store in the channel table. In channel
scan process, the OSD can display the number of channels which had been found. 4. Add on CH Search: Add channels which are new found. 5. Channel List: Show the Channel List. User can edit (add/delete) the channel numbers. 6. Channel Labels: Show the NTSC / ATSC TV Channel Labels menu for user modifying channel labels specifically. 7. FAV Channel Setting: Show the Favorite Channel List. User can edit (add/delete) the favorite channels.
VIDEO MENU The Video menu in most source modes shows as below. It provides several video adjustment items for user fine tuning the video display. Only in VGA source mode, the Video menu simply provides Picture mode, Color Temp, Backlight, Aspect Ratio, Preset items.
1. Picture Mode: Adjust the best picture appearance from selecting the preset value of Vivid, Standard, Eco, Movie, or Personal. 2. Brightness: Video brightness adjustment, the tuning range is 0 ~ 100. 3. Contrast: Video contrast adjustment, thetuning range is 0 ~ 100. 4. Sharpness: Video sharpness adjustment,the tuning range is 0 ~ 100. 5. Color: Video color chroma adjustment,the tuning range is 0 ~ 100. 6. Tint: Video tint adjustment, the tuning range is R50 ~ G50. 7. Color Temp: Three color temperature modes. (Normal / Warm / Cool) 8. Noise Reduction: Gives four NR effect degrees, such as: Low, Mid, High and Off. 9. Adaptive Contrast: Choose On or Off to adjust the gamma after analyzing the input signal automatically. 10. Backlight: Backlight strength adjustment,the tuning range is 0 ~ 30. 11. Aspect Ratio: Choose the display aspect: Normal, Zoom1, Wide, Zoom2, or HDMI PC mode. 12. Preset: Restore the default video settings.
8
AUDIO MENU The Audio menu in TV mode shows as below. It provides audio adjustment for user to modify the audio setting. Audio language setting is only available with ATSC TV source, the option is disable under other source modes.
Sound Mode: Choose the audio mode: Personal, Music, or Speech. 2. Bass: Bass tone adjustment, the tuning range is 0 ~ 63. (The default state is enabled.) 3. Treble: Treble tone adjustment, the tuning range is 0 ~ 63. (The default state is enabled.) 4. Balance: Audio balance adjustment, the tuning range is L50 ~ R50. 5. Audio Source: Select the audio source from Mono, Stereo, or SAP. (This function works in ATV only.) 6. Audio Language: Change the audio language setting on ATSC TV programs. The number of the supported
audio languages depends on the ATSC TV programs. (English / Français / Español) 7. SPDIF: Digital audio output format. Select from RAW and PCM. (This function works in DTV only.) 8. Speaker: Choose to turn on / off the TV internal speaker. The digital audio output signals and earphone output
signals will not be turned off even though the TV speaker is off. The default setting is On. 9. AVL: Choose On or Off to adjust volume to be consistent across programs and channels automatically. 10. Preset: Restore the default audio settings.
FEATURE MENU The Feature menu in TV mode shows as below. This menu gives users the most flexibility to satisfy their generally demands. According to the various requirements in different source modes, certain features should be hidden (disable) on the menu. The detailed footnotes will be described clearly below.
1. Menu Language: Select the menu display language. (English / Français / Español) 2. Time: Set current time. The sub-menu includes Time Mode, Time Zone, and Daylight Savings. [Time Mode] Choose from Auto or Manual. [Time Zone] Set current time zone. [Daylight Savings] Set to On or Off.
9
3. Transparency: Adjust the transparency of the on-screen menu from range 0 to 10.
4. Password Setting: Change the 4-numeral parental control password. Three steps are required for changing the password: Enter Old Password -> Enter New Password ->Confirm New Password. Note: This item is only available in TV, Composite and S-Video source modes. The default password is 0 0 0 0 .
5. Parental Control: Provide the parental Control (V-chip) function setting. Before entering the Parental Control sub-menu, user has to key in the password first. Enter the Parental Lock item, then the user can modify the restricted table about MPAA or TV Rating respectively. While exiting the sub-menu, the parental control function is working. The inhibitive channels or source signals can be unlock through key in the correct password. Note: This feature is only available in TV, Composite and S-Video source modes.(The default password is: 0 0 0 0.)
[Button Lock] – Select On or Off to lock or unlock the control buttons on the side panel of the TV. When this function enables, the control buttons on your TV will be locked and TV only can be controlled by remote control only. [Block Unrated TV] – When Block Unrated TV is set to on, your TV will block unrated program. [USA Parental Locks] – Set the parental control level by MPAA or TV Rating. [Canadian Parental Locks] – Set the parental control level by English Rating or French Rating. [Open V-Chip] – Open V-Chip is an advanced V-Chip rating system for digital channels that are received. The rating table will be updated by downloading the RRT5 data for blocking.
10
6. Closed Captions: Select a closed caption options. (Off / On / With Mute) 7. Analog Captions: Select an analog caption options. (CC 1-4 / TEXT 1-4) 8. Digital Captions: Select a digital caption options. (SERVICE 1-6) 9. Digital Captions Setup: Provide numerous options for setting the digital closed caption style in the sub-menu. [Style] – Set to Automatic or Customer mode. If Custom mode is selected, user can modify the detail styles described below. The setting result will be shown immediately on the bottom of the submenu OSD. Note: This feature is only available in Digital TV (ATSC) mode.
[Size] – Digital closed caption font size, which can be set as Automatic, Small, Normal, or Large. [Font] – Digital closed caption font style,which can be chosen as Automatic, Default,or Font 1 ~ 7. [Text Color] – Automatic / White / Red / Green / Blue / Yellow / Magenta / Cyan / Black. [Text Opacity] – Automatic / Solid /Flashing / Transparent / Translucent. [Background Color] – Automatic /Black / White/ Red / Green / Blue / Yellow /Magenta / Cyan. [Background Opacity] – Automatic /Solid / Flashing / Transparent / Translucent. [Edge Effect] – Automatic / None/ Raised / Depressed / Uniform / Left / Shadow / Right Shadow. [Edge Color] – Automatic / Red / Green / Blue / Yellow / Magenta / Cyan / Black / White. 10. Input Labels: User can edit the input labels. 11. Component Setting: This option only shows and is available in component mode,which provides fine tuning component display. [Phase] – Adjust Picture Phase to reduce Horizontal-Line noise. The tuning range is from 0 to 31. [Preset] – Restore the default component setting values.
12. MultiMedia Menu: This option shows the photos in JPEG formats and plays the music in MP3 formats that stored in a USB storage device.Note: File number is limited to 1000 files. JPEG sizes are limited as followed: For 19"/32": 10928x6114 For 24"/42": 15360x8640 There are two ways to enter JPEG Viewer and MP3 MusicBox interface: After plugging USB storage device into USB hub, Multimedia List menu will display.
Select MultiMedia Menu in Feature Menu to choose JPEG Viewer or MP3 MusicBox. These two items are activated only if the USB storage device is plugged into the USB hub.
[JPEG Viewer] Press Menu to display control menu. Press Enter to enlarge the selected photo (orange frame) in browser. Image Delay: Set display time for each picture in slide show. There are three options: Fast, Slow, and Normal. Music On Slide Show: Enable background Music during slide show. It will play with the MP3 file sequence in current folder repeatedly. Music On Slide Show item will be grayed out if there is no MP3 file in current folder.
Start Slide Show: Enter Slide Show mode.
11
Rotate Photo: Rotate selected picture. (0/90/180/270)
•• Back to Upper Folder: Return to the upper folder. •• Back to Root Folder: Return to root folder. •• Back To Browser: Return to Browser mode. (Photo page with control menu.) •• Exit: Exit JPEG Viewer and return to original source. (Browser with Control menu.)
[MP3 MusicBox] •• ListInfoBar (at the bottom): This part contains play list information as: “Current Directory”, “Total File(s)”,“Total Folder(s)”, “Current Item” in current directory and Key Help Bar. •• PlayList (on the right side): This part contains MP3 music files. ••ControlPanel (on the left side): Bass, Treble, Balance, Volume: Adjust the audio tone. Mute Screen: This provides an option for enabling (On) or disabling (Off) auto turn-off backlight feature while playing MP3 media. The setting status is valid in MP3 media player interface only. After setting to On state, backlight will be turned-off automatically after 10 seconds no any key pressed. Press any key to turn on the TV immediately; but if there’s no other keys pressed after 10 seconds, it will be turned-off again. Preset: Resetting MP3 relative audio parameters to the default values. Exit MP3MusicBox: Exit MP3MusicBox interface.
13. Reset to Default: Restore all the default settings.
VGA MENU This option only shows and is available in VGA mode, which provides several items for the VGA display fine tuning. 1. H-Position: Adjust the horizontal position of the picture. (0-40) 2. V-Position: Adjust the vertical position of the picture. (0-16) 3. Clock: Adjust picture clock to reduce Vertical-Line noise. (0-16) 4. Phase: Adjust picture phase to reduce Horizontal-Line noise. (0-31) 5. Auto Adjust: Adjust the settings automatically. 6. Preset: Restore the default VGA setting values.
12
2.3 Front Panel Control Knobs
1. VOL + VOL +: Press to increase the sound volume level.
2. VOL - VOL -: Press to decrease the sound volume level.
3. CH CH : Press to select the next higher Programme number.
4. CH CH : Press to select the next lower Programme number.
5. MENU Menu key: Press to open or exit the OSD (on-screen display) menu.
6. INPUT Input key: Press to select the input source.
7. POWERPower key: Press to turn on / off (standby) the TV set. (Press to turn on TV after the power on status, LED had changed to the Blue colour and stopped flashing.)
13
2.4 How to Connect
1. HDMI – Connect the primary source for digital video such as a DVD multimedia player or set top box through this
all digital connector.
2. PC IN – Connect the video and audio cables from a computer here.
3. AV IN (AV/S-VIDEO) – Connect the input source for composite video devices, such as a VCR or video game. Use
the white and red connectors to connect the external audio from the same source. The signal being carried by the
S-Video cable and connector, if connected, will take priority over the Video RCA connector (yellow connector).
444 COMPONENT (Y/Pb/Pr with Audio L/R) – Connect the primary source for component video devices such as a
DVD Player or set top box here. Use red for Pr, blue for Pb, green for Y, red for right audio (R) and white for left
audio (L) inputs.
5. ANTENNA/CABLE DIGITAL/ANALOG – Connect to an antenna or digital cable (outof- the-wall, not from Cable
Box) for Digital TV.
6. SPDIF (Optical Digital Audio Out) – When a digital audio signal is associated with the input selected for viewing,
the digital audio will be available on this SPDIF connection to your home theater system.
7. USB PORT – Insert USB storage device to the USB port to view photos or listen to music.
8. Earphone Output – Connect to the headphones. When the headphone is inserted to the plug, all the speakers
will be muted.
Once your equipment is connected, use the following procedure to view the input signal:
Press the Source button on the remote control to select the relevant source to view. (ex: Press Comp
button to select “Component” if you have connected a video recorder to Component socket.)
14
3. Input/Output Specification 3.1 Input Signal Connector
D-SUB
Pin No. Description Pin No. Description
1 Red Video 9 No Pin
2 Green Video 10 Sync GND
3 Blue Video 11 SDA(Remote Control)
4 SCL(Remote Control) 12 Serial Data for DDC
5 Ground 13 H. Sync
6 Red Ground 14 V. Sync
7 Green Ground 15 Serial Clock for DDC
8 Blue Ground
HDMI
Pin No. Description Pin No. Description
1 TMDS Data2+ 11 TMDS Clock Shield
2 TMDS Data2 shield 12 TMDS Clock-
3 TDMS Data2- 13 CEC
4 TMDS Data1+ 14 NC
5 TMDS Data1 shield 15 SCL
6 TMDS Data1- 16 SDA
7 TMDS Data0+ 17 DDC/CEC Ground
8 TMDS Data0 shield 18 +5V Power
9 TMDS Data0- 19 Hot Plug Detect
10 TMDS Clock+
15
3.2 Input Signal Timing HL32D2 Analog RGB
VESA MODES
Horizontal Vertical
Mode Resolution Total Nominal Frequency(KHz)
Sync Polarity
Nominal Freq.(Hz)
Sync Polarity
Nominal Pixel Clock
(MHz)
VGA640x480@60Hz 800 x 525 31.469 N 59.940 N 25.175 640x480@72Hz 832 x 520 37.861 N 72.809 N 31.500 640x480@75Hz 840 x 500 37.500 N 75 N 31.500
DOS 720x400@70Hz 900 x 449 31.469 N 70.087 P 28.322
SVGA
800x600@56Hz 1024 x 625 35.156 P 56.250 P 36.000 800x600@60Hz 1056 x 628 37.879 P 60.317 P 40.000 800x600@72Hz 1040 x 666 48.077 P 72.188 P 50.000 800x600@75Hz 1056 x 625 46.875 P 75 P 49.500
XGA1024x768@60Hz 1344 x 806 48.363 N 60.004 N 65.000 1024x768@70Hz 1328 x 806 56.476 N 70.069 N 75.000 1024x768@75Hz 1312 x 800 60.023 P 75.029 P 78.750
CVT-0.92M9 1280x720@60Hz 1664 x 748 44.722 N 59.855 P 74.500 WXGA 1280x768@60Hz 1440 x 790 47.396 P 59.995 N 68.250 WXGA 1360x768@60Hz 1720 x 795 75.000 P 60.020 P 162.000
HL42XD2 Analog RGB Horizontal Vertical
Resolution Total Nominal
Frequency (KHz)
Sync Polarity
Nominal Freq.(Hz)
Sync Polarity
Nominal PixelClock (MHz)
640x480@60Hz 800 x 525 31.469 N 59.940 N 25.175 640x480@72Hz 832 x 520 37.861 N 72.809 N 31.500 640x480@75Hz 840 x 500 37.5 N 75 N 31.500 720x400@70Hz 900 x 449 31.469 N 70.087 P 28.322 800x600@56Hz 1024 x 625 35.156 P 56.25 P 36.000 800x600@60Hz 1056 x 628 37.879 P 60.317 P 40.000 800x600@72Hz 1040 x 666 48.077 P 72.188 P 50.000 800x600@75Hz 1056 x 625 46.875 P 75 P 49.5 1024x768@60Hz 1344x806 48.363 N 60.004 N 65.000 1024x768@70Hz 1328x806 56.476 N 70.069 N 75.000 1024x768@75Hz 1312x800 60.023 P 75.029 P 78.750 1280x720@60Hz 1664x748 44.772 N 59.855 P 74.5 1280x768@60Hz 1440x790 47.396 P 59.995 N 68.250 1280x1024@60Hz 1688x1066 63.981 P 60.020 P 108.000 1360x768@60Hz 1792x795 47.712 P 60.015 P 85.500 1440x900@60Hz 1600x926 55.469 P 59.901 N 88.750 1680x1050@60Hz 2240x1089 65.290 N 59.954 P 146.25 1600x1200@60Hz 2160x1250 75.000 P 60.000 P 162.00 1920x1080@60Hz 2200x1125 67.500 P 60.000 P 148.500
16
HL32D2 Component
HL42XD2 Component
HL32D2&HL42XD2 HDMI VESA MODES
Horizontal Vertical
Mode Resolution Total Nominal
Frequency(KHz)
Sync Polarity
Nominal Freq. (Hz)
Sync Polarity
Nominal Pixel Clock
(MHz) DOS 720 x 400 900 x 449 31.469 N 70.087 P 28.322
VGA 640 x 480 800 x 525 31.469 N 59.940 N 25.175
SVGA 800 x 600 1056 x 628 37.879 P 60.317 P 40
XGA 1024 x 768 1344 x 806 48.363 N 60.004 N 65
WXGA 1280 x 768 1664 x 798 47.396 P 59.995 N 68.25
CVT-0.92M9 1280 x 720 1664 x 748 44.772 N 59.855 P 74.5
WXGA 1360x768@60Hz 1720 x 795 75.000 P 60.020 P 162.000
1080P 1920 x 1080P 2200 x 1125 67.5 60, 148.5
720P 1280 x 720P 1650 x 750 45.00 60, 74.25
1080i 1920 x 1080i 2200 x 1125 33.75 60, 74.25
480P 720 x 480P 858 x 525 31.50 60, 27.03
480i 720 x 480i 1716 x 525 15.75 60, 13.51
Industry Code
Input signal Format
Display performance description
Interlacerate
Partition
Total Line Per Frame
HorizontalFrequency
(KHz) Vertical
Frequency (Hz) SamplingFrequency
(MHz) ASPECT
480i 720 x 480 i 2:1 525 15.75 60 13.51 480P 720 x 483 P 1:1 525 31.50 60 27.03 720P 1280 x 720 P* 1:1 750 45 60 74.25 16:91080i 1920 x 1080 i* 2:1 1125 33.75 60 74.25 16:9
Industry Code
Input signal Format
Display performance descrip
Interlacerate
Partition
Total Line Per Frame
HorizontalFrequency
(KHz) Vertical
Frequency (Hz) SamplingFrequency
(MHz) ASPECT
480i 720x480i 2:1 525 15.75 60 13.51
480P 720x480P 1:1 525 31.50 60 27.03
720P 1280×720P* 1:1 750 45 60 74.25 16:9
1080i 1920×1080i* 2:1 1125 33.75 60 74.25 16:9
1080P 1920x1090P 1:1 1125 67.5 60 148.5 16:9
17
4. Mechanical Instructions Note: Below are only the critical steps of disassembing the HL32D2 and HL42XD2 TV, and may be there is a little difference for the following pictures with the actual TV, only for your reference. HL32D2 Front and Rear View
1. Remove the BASE ASS’Y Unscrew the 4 screws as Fig 1.
Fig 1 2. Remove the REAR COVER ASS’Y Unscrew the 13 screws as Fig 2.
Fig 2
18
3. Remove all the detachable HARNESS or CABLE. Disconnect the harness and cable as Fig 3.
Fig 3 4. Remove the MAIN, POWER, INVERTER BOARD and BASE-SUPPORT. Unscrew the 22 screws as Fig 4.
Fig 4
19
5. Remove the BEZEL and PANEL. a. Unscrew the 4 screws as Fig 5a. b. Remove the 4 washers as Fig 5b.
Fig 5a
Fig 5b The BEZEL.
Fig 5
20
HL42XD2 Front and Rear view
1. Remove the NECK COVER and STAND ASS’Y. a. Unscrew the 5 screws to remove NECK COVER as Fig 1a. b. Unscrew the 1 screw to remove STAND ASS’Y as Fig 1b.
Fig 1a
Fig 1b
21
2. Remove the REAR COVER. Unscrew the 12 screws for rear cover and 3 screws for HDMI commector as Fig 2.
\Fig 2
3. Remove the all the detachable HARNESS. Disconnect all the detachable HARNESS as Fig 3.
Fig 3
22
4. Remove the VESA BRACKET LCM. Unscrew the 2 screws to remove VESA BRACKET LCM as Fig 4.
Fig 4
5. Remove the MAIN, POWER and INVERTER BOARD. Unscrew the 17 screws as Fig 5.
Fig 5
23
6. Remove the STAND BRACKET and BOLT. Unscrew the 7 screws and 4 bolts as Fig 6.
Fig 6
7. Remove the BEZEL and PANEL. Unscrew the 6 screws as Fig 7.
Fig 7
24
The BEZEL.
25
5. Repair Flow Chart 1. No power
No power (LED “Off”)
Check the AC input and the power is “On”?
Power “On”
Check the IR board and LED
Replace the IR board
Replace the main board
Power board output=5V? Replace the power board
No
Yes
No
Yes
No
26
2. Can’t start
Can’t start (LED Red)
Replace the main board
Replace the Power board
No
Yes
No
Yes
No
No
Power board output 24V?
Check the power key is under control?
Check the IR receiver is normal?
Replace the power board
Replace the key board
Yes
Replace the IR board
27
3. No display
Check the B/L signal is available?
Replace main board
Replace the power board
Panel Vcc = 5 V?
Replace the Panel
No display (LED Blue)
Replace the main board
Check the backlight is “On”?
Check the LVDS cable
Reinsert or replace the LVDS cable
Replace the main board
Replace the Panel
No
Yes
Yes No
Yes
No
No
YesYes
No
Yes No
Power board output 24V?
Check TV is under control and power on/off by remote control and power key?
28
4. Sound problem
No sound or sound abnormal
Check the TV is muted, adjust the volume or enter the menu to reset?
Reinsert the audio cable or change the TV system
Replace the cable
Replace the speaker
Replace the main board
No
Yes
No
Check the cable between the speakers and main board is ok?
Check the speaker resistance value is in spec (Remark: The value is marked on the speaker)?
Check the audio source connection and the TV system are correct
Yes
No
No
Yes
29
5. Remote Control malfunction
6. OSD is unstable or can’t work normally
Remote Control malfunction
Replace the battery
Replace the remote control
Whether the IR board is abnormal?
Yes
No
Replace the IR board
Replace the main board
No
Yes
No
Yes
Use the other remote controls
Check the remote control battery is not properly placed or no power?
Key board connected properly? Reconnect the key board
Buttons are ok? Replace the button function
Yes
No
Key board is ok? Replace the key board
Replace the main board
No
Yes
No
Yes
OSD is unstable or can’t work normally
30
6. PCB Layout 6.1 Main Board
715G3269M01001005K
31
32
33
34
6.2 Power Board HL32D2 715G3332 1
35
715G3645P01W30003S
36
HL42XD2 715G3351 1
37
38
39
715G3358 2
40
6.3 Key Board 715G3293 1
6.4 IR Board 715T3294 1
41
7. Adjustment It’s no need to adjust the white balance for this model, do ADC only.
Step1: Turn on the TV, press “Menu”, then press number key 1 9 9 9 and “ENTER”, it will achieve the factory
mode. Take the following picture for example:
Step2: Change TV, press the “Current Source” to Component mode and change signal to 1080i mode, press the
“Auto Color”;
Step3: Change TV, press the “Current Source” to PC mode and change signal to PC TIMING 137(1024X768);
Pattern 147 (16 Grays), press the “Auto Color”.
42
8. Block Diagram
5VT8V3P12VU708 G9084T43UP12V
U706 SC194BMLTRT
CVBS
POWERBOARD
ZR39775HGCF
FLASH ROMMX25L3205DMI-12G
P24V
DDRIIH5PS5162FFR-25C
LCD PANELLVDS
P24V
EJTAG
GPIO
M24C64
Inverter & Audio Amplifier
U704 SC4524BSETRT
+5VSB+5VSB
1V8_STB
VCC5D
U707 SC4524BSETRT
3V3_STB
D3V3U703 G1084-33T43Uf
VCC5D
VCC1V1
U702 AIC1084-18PE
U710 SC4525BSETRTP12V
PANEL_5V
CVBS
VIDEO1
TunerENV56S02D8F
VIF
CVBS
VIDEO2
LINE OUTR/L
Audio AmplifierTPA3121D2PWPR
SPEAKER
S/PDIF
Earphone AmplifierTPA6113A2DR
EAR PHONE
TL072CDR
S-VIDEO1 Y/C
YPbPr
YPbPr1 AUDIO-R\L
SN74LVC1G17
AV1 AUDIO-R\L
I2C
AV2 AUDIO-R\L
Hsync, Vsync
AF24BC02
YPbPr2 AUDIO-R\L
YPbPr1
VGA
YPbPr2
RGB
VGA AUDIO-R\L
YPbPr
For TPA6113A2DR
U404 MX25L3205DMI-12GFor SPI Flash
3V3_STB
FOR VGA EDID
P24V
U602 TPA3123D2PWPR
VCC1V1
U405 M24C64
POWER INPUT TYPE +5VSB , P12V, P24V
For ZORAN standby pow er
D3V3
FOR TUNER+5V8.3V
For EEPROM
VCC5D
D3V3
U604 TPA6113A2DR
For Digital Circuit
U707 SC4524BSETRT
5VTU709 AZ1117D-5.0-E1
+5VSB
U401 ZR39775HGCF
For ZR39775 Core
+5VSB
U703 G1084-33T43Uf
U401 ZR39775HGCF
P12V
TU201U708 G9084T43U
FOR MCU 1V8_STB
FOR PANEL LVDS
For ZR39775
U208 AF24BC02-SI
FOR Inverter
FOR TPA3123D2PWPR
TMDS
TMDS
HDMI-3 TMDS TMDS
HDMI-1
TMDS
TPD12S520DBTR
SiI9185A
HDMI-2
TMDS
HDMI-4
U702 AIC1084-18PE1V8_STB
U706 SC194BMLTRT
U401 ZR39775HGCFD1V8
For DDR IIU410 H5PS5162FFR-25C
For ZR39775U704 SC4524BSETRT
U709 AZ1117D-5.0-E1
D1V8
43
9. Wiring Diagram HL32D2
Key Board
Power Board U401
3 Pi
n (2
ndN
C)
CN
801
Panel
IR Board
CN
902
CN01
5 Pi
n
CN
802
Speaker R/L
5 Pi
n
24 Pin
Scaler IC
ZR39775HGCF
LVDS Cable
CN405
CN
701
12 P
in
10 Pin
12 P
in
CN403
Tuner
4 Pin
CN01
4 Pi
n
CN
606
InverterBoard
3 Pi
n 3
Pin
6 Pi
n C
N88
02
CN
8801
C
N88
03
TU201
CN901
44
HL42XD2
Key Board
Power Board
U401
3 Pi
n (2
ndN
C)
CN
801
Panel
IR Board
CN
903
CN01
5 Pi
n
CN
802
Speaker R/L
5 Pi
n
24 Pin
Scaler IC
ZR39775HGCF
LVDS Cable
CN405
CN
701
12 P
in
10 Pin
12 P
in
CN403
Tuner
4 Pin
CN01
4 Pi
n
CN
606
Inve
ter B
oard
6
Pin
3 Pi
n C
N88
01
CN
8802
TU201
CN901
CN
8810
C
N88
09
CN
8808
C
N88
07
CN
8806
C
N88
05
CN
8804
C
N88
03
To panel
45
10. Schematic Diagram 10.1 Main Board 715G3269M01001005K03) Tuner
C267
1uF/25V
SIF_IN
1 2
L203
0.22uH 5%
R206 100R 1/10W 5%
1 2
L201
0.22uH 5%
C219
NC/22pF
C220
NC/22pF
R204
2K2 1/10W 5%
R203
2K2 1/10W 5%
C214 0.001uF
D3V3
DEMOD_RSTN8
IF_AINNAF2
IF_AINPAE2
SIF_AINNAF4
IF_AGCAF7RF_AGCAF8
DMOD_RST_NAC8 MPEG_FAILAC7
PARAM0AE7 SA_DATAAC6
DEMOD_CLKOAD8
SIF_AINPAE4
IF_RBIASAD3
IF_VINBIASAD2
IF_VCMAD1
IF_VREFNAF1
IF_VREFPAE1
IF_DVAL_GPIOAA5
Demodulator
U401P
ZR39775HGCF-BD
R210 NC/20K 1/10W 5%
R205 100R 1/10W 5% C210
82pFI2C1_SDAI2C1_SCL
C213 0.1uF 16VC215 0.1uF 16V
IF_AGC
C268
22pF
C269
22pF
1 2FB203 600 OHM
R213
NC/75 1/10W 5%
PANEL_CTRL2
TU_GND
1 2FB202 NC/600 OHM
D3V3
1 2FB201 600 OHM
C203
0.1uF/16V
TV_CVBS 4TUNER_CVBS
C209
NC
C217
NC/0.0022uF
C216
NC
IF_AINP
PANEL_CTRL28,10
C202
NC/0.0022uF
C201
0.1uF/16V
TU_GNDPlace R211 & C221close to U401
11
13
0402
21
3
1617
4
7
C264
NC/0.0022uF
5V :BB=15mA(MAX) +B=140mA(MAX) VB=70mA(MAX)
1
18
ENV56S02D8F
8
12
0402
19
0402
15
5
20
6
910
0402
Place parts very close to U401
14
2
SIF_IN
R233 NC/33R 1/10W 5%
NC 1
BB 2
AGC3
NC 5
BT Monitor 6
NC 8
NC 9
NC10
NC 11
SCL 13
SDA 14
NC 15
IF AGC 16
+B 17
TH1 22
TH2 23
TH3 24
TH425
IFD-out1 19
IFD-out2 20
IF Monitor 21
TU201 TUNER
C262 0.0022uF
If SIF_IN is not use,C207 change to 0.01uF
R211 2K 1/10W 5%
C221
0.1uF/16VR212 NC/75 1/10W 5%
C218
0.1uF/16V
C206 0.0022uF
SIF_N
1TP1 1TP2
R201 NC/0R05 1/10W 5%
TUNER_CVBS
R209 4K7 1/10W 5%
IF_AINN
PARAM0
RF_AGC
OE2/GADR0_ALEW22
STV1/GDAT0Y22 OE1/GDAT1Y23 CPV/GDAT2Y24 STH2/GDAT3Y25 STH1/GDAT4Y26
TP/GDAT5W25 CPV2/GDAT6W24
RVS/GDAT7W23
GOE_NV23
GWE_NV22
STV2/GCS_N0V24 GPO/GADR1_CLEU22
Guest Bus
U401H
ZR39775HGCF-BD
IF_AGC
NC68K22
No Connect Pins
U401L
ZR39775HGCF-BD
TV_CVBS
R202 NC/47R 1/10W 5%
C207
0.01uF
12
L202
0.15uH 5%
C204 NC/0.1uF/16V
C208 0.001uF
C265
0.0022uF
C266
0.0022uF
SIF_P
5VT
I2C1_SCL 5,7I2C1_SDA 5,7
IF_AP
C205 0.01uF
C211 0.1uF 16VC212 0.1uF 16V
IF_AN
R207 3K9 1/10W 5%
R208 33R 1/10W 5%
46
04) AV/YPbPr Inputs
Pr1
VCC5D
Y1
YPbPr1_PbPb1
1 2FB215 30 OHM
R242
75R 1/10W 1%
R243
75R 1/10W 1%
88G 7813C19C
1
2
3
4
5
6
7
8
9
JACK
CN203
S2Y
R244
75R 1/10W 1%
2
1
4
3
6
5
CN205
JACK
CV2
C222 0.22uFC223 0.22uF
C224 0.22uFC225 0.22uF
C230 0.22uFC231 0.22uFC232 NC/0.22uF
C236 0.22uFC237 0.22uFC238 0.22uF
C241 0.22uFC242 0.22uF
C240 0.22uF
C245 0.22uFC244 0.22uF
C246 0.22uF
R248
75R 1/10W 1%
R250
75R 1/10W 1%
1 2FB220 30 OHM
12
ZD202
VPORT0603100KV05
1 2FB219 30 OHM
12
ZD201
VPORT0603100KV05
YPbPr2_Y
Pb2
Y2
Pr2
1 2FB218 30 OHM
YPbPr2_Pb
YPbPr2_Pr
C248
100pF
TV_CVBS3
C249
100pF
CV1
PANEL_CTRL1VGA_EDID_WP
R235 NC/33R 1/10W 5%
R237
10K 1/10W 5%
S1C
1 2FB204 30 OHM
4
2
3
5
1
6
CN202 DIN JACK
1 2FB205 30 OHM
S1Y
1 2FB206 30 OHM
1 2FB207 30 OHM
1 2FB208 30 OHM
AV2_Audio_L 11
AV2_Audio_R 11
1 2FB209 30 OHM
R231
75R 1/10W 1%
AV2_CVBS
R226
75R 1/10W 1%
VGA_EDID_WP6
S2_Y
S2_C
R225
75R 1/10W 1%
S2_Y
C243 0.01uF
C247 0.01uF
R277 100R 1/10W 5% AV1_S_DET 5
C239 0.01uF
YPbPr2_PrYPbPr2_Y
VGA_R
YPbPr2_Pb
VGA_GVGA_B
12
ZD207
VPORT0603100KV05
YPbPr1_YYPbPr1_Pr
YPbPr1_Pb
AV2_R
R219 75R 1/10W 1%
AV2_CVBS
R220 75R 1/10W 1%AV1_CVBS
R222 75R 1/10W 1%
I/O11GND2I/O23
I/O34
VDD5
I/O46
U204AZC099-04S
FB210 0R05 1/10W 5%
C270
NC/22pF
C271
NC/22pF
C272
NC/22pF
S1_YS1_C
S2C
AV1_CVBS
R276 10K 1/10W 5%
R236
10K 1/10W 5%
D3V3
VGA_HSYNC
S1_Y
S1_C
VGA_VSYNC
I/O11GND 2I/O23
I/O34
VDD5
I/O46
U203AZC099-04S
PANEL_CTRL110
R232 10K 1/10W 5%
R234 10K 1/10W 5%
VGA_B6
VGA_R6VGA_G6
R268 NC/75R 1/10W 1%R280 NC/75R 1/10W 1%
R281 75R 1/10W 1%
S2_C
1 3
42
85
6
7
CN201JACK
C250 4.7uF/10V
C251 0.47uF/16V
R238 62K OHM 1/10W
VGA_VSYNC6VGA_HSYNC6
AV1 Input(Rear)
88G 78 1360S
88G 100 11 ST
AV2 Input(Side)
Place parts very close to U401
YPbPr2Input
88G 78 13932 C
YPbPr1Input
88G 78 1360C
TV_CVBS
Active L
Active L
R216
75R 1/10W 1%
VIN_R2W2
VIN_G2W1
VIN_B2Y1
SOG_IN0T4
SOY_IN0V2
VGA_R0T2
VGA_G0T1
VGA_B0T3
VIN_R1U2
VIN_G1U1
VIN_B1V1
SOY_IN1Y2
AFE_HS_INR5
AFE_VS_INT5
VCOMAB1
VREFPAA1
VREFNAA2
SVIDEO0YU3
SVIDEO0CV3
CVBS0AA3
SVIDEO1YU4
SVIDEO1CV4
CVBS1AB3
SVIDEO2YU5
SVIDEO2CV5
CVBS2AB4
CVBS3AA4
RSETL4
REFNODE_GND_CVBSW3
REFNODE_GND_RL5 REFNODE_GND_GK5
REFNODE_GND_BM5
REFNODE_GND_ChN5
VGA_SCL_GPIO_P28AB11
VGA_SDA_GPIO_P29AE9
Video In I/F
U401F
ZR39775HGCF-BD
I/O11GND2I/O23
I/O34
VDD5
I/O46
U201AZC099-04S
2
1
4
3
6
5
CN204
JACK
R217
75R 1/10W 1%
R221
75R 1/10W 1%
R249
75R 1/10W 1%
AV2_S_DET 8
D3V3
R279 100R 1/10W 5%R278 10K 1/10W 5%
AV2_L
FB211 0R05 1/10W 5%
VCC5D
YPbPr1_Y
1 2FB216 30 OHM
VCC5D
1 2FB217 30 OHM
VCC5D
YPbPr1_Pr
I/O11GND2I/O23
I/O34
VDD5
I/O46
U212AZC099-04S
47
05) HDMI Inputs
HD3V3
HD
MI0
_D0N
HD
MI0
_D1N
HD
MI0
_D2P
HD
MI0
_D2N
HD
MI0
_D1P
HD
MI0
_D0P
HDMI_HPD1
DD
C2_
SCL
DDC0_SCL
DD
C2_
SD
A
Line-11
Line-22
VDD3
Line-34
Line-45 NC 6NC 7GND 8NC 9NC 10
U509
NC/AZ1045-04QUHDMI_CEC 6
HD
MI2
_5V
DDC0_SDA
R516 100R 1/10W 5%DDC1_SCLDDC1_SDA
3V3_STB
HDMI_CEC
HD1V8D
HDMI_CEC HDMI3_CEC 6
VCC5D
TMDSD0+7
TMDSD0-9
TMDSD1+ 4
TMDSD1- 6
TMDSD2+ 1
TMDSD2- 3
SCL 15
DSHLD1 5
VCC518
CSHLD0 11
HPD 19
NC14
DSHLD0 2
CEC 13SDA 16
DDC_GND17
DSHLD2 8
TMDSC+10
TMDSC-12
SHLD020
SHLD121
SHLD2 22
SHLD3 23
CN502 HDMI
R517
1K8 1/10W 5%
R503
NC/10K 1/10W 5%
R512
NC/10K 1/10W 5%
R518
1K8 1/10W 5%
R513
NC/10K 1/10W 5%
R519
10K 1/10W 5%
R522
10K 1/10W 5%
C502
NC/0.1uF/16V
TMDSD0+ 7
TMDSD0-9
TMDSD1+4
TMDSD1-6
TMDSD2+ 1
TMDSD2- 3
SCL15
DSHLD1 5
VCC5 18
CSHLD0 11
HPD 19
NC14
DSHLD02
CEC 13SDA16
DDC_GND 17DSHLD2 8
TMDSC+ 10
TMDSC-12
SHLD020
SHLD121
SHLD222
SHLD323
CN501 HDMI
VCC5D
TMDSD0+7
TMDSD0-9
TMDSD1+ 4
TMDSD1- 6
TMDSD2+1
TMDSD2-3
SCL 15
DSHLD1 5
VCC518
CSHLD011
HPD19
NC 14
DSHLD0 2
CEC 13SDA 16
DDC_GND17
DSHLD2 8
TMDSC+10
TMDSC- 12
SHLD_GND120
SHLD_GND2 21
SHLD1 22
SHLD2 23
SHLD3 24
SHLD425
SHLD526
CN503 HDMI
Line-11
Line-22
VDD3
Line-34
Line-45 NC 6NC 7GND 8NC9NC10
U508
NC/AZ1045-04QU
C501
NC/0.1uF/16V
R510
820R 1/10WR 5%
R508 10K 1/10W 5%
C509
0.1uF/16V
Line-11
Line-22
VDD3
Line-34
Line-45 NC 6NC 7GND8NC9NC10
U504
NC/AZ1045-04QU
Line-11
Line-22
VDD3
Line-34
Line-45 NC 6NC 7GND 8NC9NC10
U506
NC/AZ1045-04QU
R521
10K 1/10W 5%
HDMI2_CLKN
HDMI1_D2NHDMI1_D2P
HDMI1_D1N
HDMI2_CLKP
HDMI1_D1P
HDMI1_5V
R502
NC/10K 1/10W 5%
VCC5D
VCC5D
88G 340 21 VD
HDMISW_RSTN8
HDMI3_SCLHDMI3_SDA
AV1_S_DET
HDMI3_HPD
Q501
NC/2SK3018
NC
HDMI0_D0N
HDMI0_D1N
HDMI0_CLKN
HDMI0_D2N
HDMI0_D1P
Run As 100 Ohm Differential Pairs
HDMI0_CLKP
HDMI0_D2P
HDMI0_D0P
Side HMDI2
R509
4K7 1/10W 5%
HDMI3_CEC
Run As 100 Ohm Differential Pairs
HDMI1_CLKP
HDMI1_CLKN
HDMI1_D0N
HDMI1_D0P
HDMI2_D0P
HDMI1_D0P
HDMI1_CLKN
HDMI1_D0N
HDMI2_D1PHDMI2_D1N
HDMI1_CLKP
HDMI2_D2P
HDMI2_CLKN
HDMI2_D0N
HDMI2_CLKP
HDMI2_D2N
C503
0.1uF/16V
HDMI1_D1P
HDMI1_D2P
HDMI1_D1N
HDMI1_D2N HDMI1_D2NHDMI1_D1P
HDMI1_D2P
HDMI1_D1N
C504
0.1uF/16V
C506
0.1uF/16V
C505
0.1uF/16V
C510
0.1uF/16V
NC
C511
0.1uF/16V
C512
0.1uF/16V
I/O11 GND2 I/O23
I/O34
VDD 5
I/O4 6
U507
NC/AZ1045-04SU
Rear HMDI1
HD3V3
Side HMDI1
R536 1K 1/10W 5%
I/O11 GND2 I/O23 I/O3 4
VDD 5
I/O4 6
U510
AZ1045-04SU
HD3V3
R511
NC/1K 1/10W 5%
HDMI0_CLKPHDMI0_CLKN
AV1_S_DET4
HDMI0_D0P
HDMI0_D1P
HDMI0_CLKN
HDMI0_D0N
1 2
FB502
120OHM
HDMI0_D2N
HDMI0_D1N
HDMI0_D2P
HDMI0_CLKP
HDMI1_5V
HDMI_HPD0
1 2FB503 120OHM1 2FB504 120OHM
R541
10K 1/10W 5%
HD3V3
3
1 2
ZD501
NC/BAT54C
R504
NC/27K 1/10W 5%
R515
27K 1/10W 5%
3V3_STB
3V3_STB
HD
MI_
HP
D1
1
2
4
3L508 NC/90 ohm
1
2
4
3L506 NC/90 ohm
1
2
4
3L505 NC/90 ohm
1
2
4
3L507 NC/90 ohm
HD
MI1
_CLK
NH
DM
I1_C
LKP
HDMI_CEC
HDMI0_D0N1
2
4
3L510 NC/90 ohm
HDMI0_D0P
R507 0R05 1/10W 5%
HDMI2_D2PD1
HDMI2_D2ND2
HDMI2_D1PC1
HDMI2_D1NC2
HDMI2_D0PB1
HDMI2_D0NB2
HDMI2_CLKPA1
HDMI2_CLKNA2
HDMI2_SCLB3
HDMI2_SDAA3
HDMI2_HPDD4
HDMI2_5VSENSEE6
HDMI2 I/F
GPIO_P18
GPIO_P20
U401D
ZR39775HGCF-BD
HDMI3_D2P
HDMI3_CLKN
HDMI3_D2N
HDMI3_D1P
HDMI3_CLKP
HDMI3_D1N
HDMI3_D0PHDMI3_D0N
TX2+ 1TX2- 2AGND 3TX1+ 4TX1-5AVCC186TX0+7TX0-8AGND 9TXC+ 10TXC- 11ExtSWING 12RESET#13LSDA/PSEL014LSCL/PSEL115HPD016AVCC18 17R0XC- 18R0XC+ 19AGND 20
R0X
0-21
R0X
0+22
AVC
C33
23R
0X1-
24R
0X1+
25AG
ND
26R
0X2-
27R
0X2+
28A
VCC
1829
DS
DA
030
DS
CL0
31R
PW
R0
32D
VDD
1833
DG
ND
34I2
CS
EL/IN
T35
HPD
136
AVC
C18
37R
1XC
-38
R1X
C+
39AG
ND
40
R1X0-41
R1X0+42
AVCC3343
R1X1-44
R1X1+45
AGND46
R1X2-47
R1X2+48
AVCC1849
DSDA150
DSCL151
RPWR152
CEC_D53
CEC_A54
AVCC3355
HPD256
AVCC1857
R2XC-58
R2XC+59
AGND60
R2X
0-61
R2X
0+62
AVC
C33
63
R2X
1-64
R2X
1+65
AG
ND
66
R2X
2-67
R2X
2+68
AVC
C18
69
DS
DA
270
DS
CL2
71
RP
WR
272
DV
DD
1873
DG
ND
74
TES
T75
HP
DIN
76
TSD
A77
TSC
L78
TPW
R/I2
CAD
DR
79
AG
ND
80
U505
SiI9185ACTU
1
2
4
3L512 NC/90 ohm
HDMI0_D2P
HDMI0_D2N
VCC5D
1
2
4
3L504 NC/90 ohm
Line-11
Line-22
VDD3
Line-34
Line-45
NC6NC7GND8NC9NC 10
U501
NC/AZ1045-04QU
1
2
4
3L502 NC/90 ohm
1
2
4
3L501 NC/90 ohm
Line-11
Line-22
VDD3
Line-34
Line-45 NC 6NC7GND8NC9NC10
U502
NC/AZ1045-04QU
VCC5D
1
2
4
3L503 NC/90 ohm
HDMI2_D1N
HDMI2_D1P
HDMI2_D0N
HDMI2_D2N
HDMI2_D0P
HDMI2_CLKN
HDMI2_CLKP
HDMI2_D2P
HDMI3_D2N
HDMI3_D0P
HDMI3_D2P
HDMI2_D1P
HDMI3_D0N
HDMI3_D1P
HDMI2_D0N
HDMI3_D1N
HDMI2_D2PHDMI2_D2N
HDMI3_CLKNHDMI3_CLKP
HDMI2_D0P
HDMI2_D1N
HDMI2_CLKPHDMI2_CLKN
HDMI_HPD2
HD
MI2
_D0N
DD
C0_
SCL
DD
C0_
SDA
HD
MI2
_D1P
HD
MI2
_D0P
HD3V3
HD
MI0
_5V
HD
MI2
_D2P
HD
MI2
_D1N
HD
MI2
_D2N
HDMI0_D1N
HDMI0_D1P
HDMI0_CLKN
HDMI0_CLKP
HDMISW_RSTN
R520
NC/1K 1/10W 5%
HDMI_HPD0
HDMI1_D2N
HDMI1_D0N
HDMI1_D2P
HDMI1_CLKN
HDMI1_D0P
HDMI1_D1PHDMI1_D1N
HDMI1_CLKP
DDC1_SCLDDC1_SDA
HDMI0_5V
HD1V8A
1 2FB506120OHM
DDC2_SDA
HDMI_HPD2
HD1V8A
C514
0.1uF/16V
C515
0.1uF/16V
DDC2_SCL
C513
0.1uF/16V
HDMI_CEC
C516
0.1uF/16V
HDMI3_5V
R535 33R 1/10W 5%I2C1_SCLR534 33R 1/10W 5% I2C1_SCL 3,7
I2C1_SDA 3,7I2C1_SDA
1
2
4
3L511 NC/90 ohm
1
2
4
3L509 NC/90 ohm
HDMI1_D0PHDMI1_D0N
1V8_STB
HDMI3_SDAHDMI3_SCL
HDMI3_HPD
HDMI1_D2PB4
HDMI1_D2NA4
HDMI1_D1PC4
HDMI1_D1NC5
HDMI1_D0PA5
HDMI1_D0NB5
HDMI1_CLKPB6
HDMI1_CLKNA6
HDMI1_SCLB7
HDMI1_SDAA7
HDMI1_HPDD6
HDMI1_5VSENSEC7
HDMI1 I/F
GPIO_P14
GPIO_P12
U401O
ZR39775HGCF-BD
1 2FB505NC/120OHM
R501
NC/1K 1/10W 5%
HDMI2_5V
C521
0.1uF/16V
HDMI3_5V
I/O11 GND2 I/O23
I/O34
VDD5
I/O46
U503
NC/AZ1045-04SU
1 2FB501NC/120OHM
C508
0.1uF/16V
C507
0.1uF/16V
HD1V8D
48
06) VGA/HDMI Inputs
HDMI4_5V
R282
NC/4K7 1/10W 5%
88G 35315F FX
VGA Input
Run As 100 Ohm Differential Pairs
I/O11GND2I/O2 3I/O34
VDD5
I/O46
U206AZC199-04S
Rear HMDI2
R284
10K 1/10W 5%
R538 4K7 1/10W 5%
88G 340 21 VD
HDMI4_5V
UART0_TX
UART0_RX
HDMI_HPD4_A
12
ZD502VPORT0603100KV05
R256 100R 1/10W 5%
R264 100R 1/10W 5%
VGA_SDA
Q5032N7002K
RGB_HSYNC
RGB_VSYNC
VGA_SCL
HDMI3_CEC
C253
NC/330pF
C254
NC/47pF
RGB_VSYNC
2 4
5
3SN74LVC1G17DBVRU207
R285 22R 1/10W 5%
R261
75R 1/10W 1%
R263
75R 1/10W 1%
R262
75R 1/10W 1%
VGA_HSYNC 4
VGA_VSYNC 4
3
1 2
ZD503
BAT54C
R532
390R 1/10W 1%
R527 7K5 1/10W 5%R526 7K5 1/10W 5%
C258
0.1uF/16V
R252 10K 1/10W 5%R251 10K 1/10W 5%
I/O1 1GND2I/O23
I/O34
VDD5
I/O46
U205AZC199-04S
R540
10K 1/10W 5%
HDMI_3V3
C252
0.1uF/16V
VGA_HSYNC_DET 8
VGA_VSYNC_DET 8
VGA_HSYNC_DET
RGB_VSYNC
R253 220R 1/10W 5%
VCC5DR265
2K2 1/10W 5%
R266
2K2 1/10W 5%
R269 33R 1/10W 5%
VGA5V
VGA5V +5VSB
D3V3
Q5022N7002K
A01
A12
A23
VSS4
SDA5SCL 6WP7VCC8
U208
AT24C02BN-SH-T
HDMI3_CEC5
HDMI_HPD4
R260 1K 1/10W 5%
Q201NC/MMBT3904
R275 33R 1/10W 5%C263
NC/0.1uF/16V
R286 NC/220R 1/10W 5%
VGA_EDID_WP
+5VSB
EDID_WP
1 2FB221 30 OHM
1 2FB222 30 OHM
1 2FB223 30 OHM
HDMI_CEC 5
HDMI4_CLKN
HDMI_CECDDC4_SDA
HDMI4_D2N
HDMI4_D1P
R283
NC
TMDSD0+7
TMDSD0-9
TMDSD1+4
TMDSD1-6
TMDSD2+1
TMDSD2-3
SCL15
DSHLD15
VCC518
CSHLD011
HPD19
NC14
DSHLD02
CEC13SDA 16
DDC_GND17
DSHLD2 8
TMDSC+10
TMDSC- 12
SHLD_GND120
SHLD_GND221
SHLD122
SHLD223
SHLD3 24
SHLD425
SHLD526
CN504 HDMI
HDMI_HPD4_A
HDMI4_D0P
HDMI4_CLKP
HDMI4_D0N
DDC4_SCL
HDMI4_D1N
C520
0.1uF/16V
HDMI4_D2P
VGA_EDID_WP 4
VGA_G
R258 1K 1/10W 5%
UART0_RX7
R270
1K 1/10W 5%
3V3_STBHDMI4_D1N
R528
7K5 1/10W 5%
VGA_VSYNC_DET
5V_SUPPLY1
LV_SUPPLY2
GND3
TMDS_D2+ 4
TMDS_GND5
TMDS_D2-6
TMDS_D1+7
TMDS_GND8
TMDS_D1-9
TMDS_D0+ 10
TMDS_GND11
TMDS_D0-12
TMDS_CK+13
TMDS_GND 14
TMDS_CK-15
CE_REMOTE_IN 16
DDC_CLK_IN17
DDC_DAT_IN18
HOTPLUG_DET_IN19
HOTPLUG_DET_OUT20 DDC_DAT_OUT21 DDC_CLK_OUT22 CE_REMOTE_OUT23
TMDS_D2+35
TMDS_GND34
TMDS_D2-33
TMDS_D1+32
TMDS_GND31
TMDS_D1-30
TMDS_D0+29
TMDS_GND28
TMDS_D0-27
TMDS_CK+26
TMDS_GND25
TMDS_CK-24
GND36 ESD_BYP37 NC38
U511
TPD12S520DBTR
R525 1K 1/10W 5%HDMI4_D1N
C519
0.1uF/16V
HDMI4_CLKP
HDMI4_SCL
HDMI4_CLKP
HDMI_HPD4
HDMI4_D2NHDMI4_D2N
HDMI4_HPD
HDMI4_CLKN
HDMI4_D0N
DDC4_SDA
C518
0.1uF/16V
DDC4_SCL
HDMI4_D2PHDMI4_D2P
HDMI4_D1P
HDMI4_CLKN
HDMI4_D1P
+5VSB
HDMI4_SDA
HDMI4_D0N
3V3_STB
HDMI4_D0P
R533
10K 1/10W 5%
+5VSB
C517
0.1uF/16V
HDMI4_D0P
R529
7K5 1/10W 5%
HDMI4_CLKP
HDMI4_D2P
HDMI4_5V
HDMI4_HPD
HDMI4_D0P
HDMI0_D2PB8
HDMI0_D2NA8
HDMI0_D1PC8
HDMI0_D1NC9
HDMI0_D0PA9
HDMI0_D0NB9
HDMI0_CLKPB10
HDMI0_CLKNA10
HDMI0_SCLB11
HDMI0_SDAA11
HDMI0_HPDD9
HDMI0_5VSENSED7
HDMI_ATESTD3
HDMI_REXTC3
HDMI0_CECD8
HDMI0 I/F
GPIO_P17
GPIO_P15
GPIO_P16
U401G
ZR39775HGCF-BD
R531 10K 1/10W 5%
HDMI4_SDA
HDMI4_CLKN
HDMI4_D2N
R530 4K7 1/10W 5%
HDMI4_D1PHDMI4_D1N
HDMI4_SCL
HDMI4_D0N
3V3_STB
C260
0.1uF/16V
2 4
5
3SN74LVC1G17DBVRU210
RGB_HSYNC
16
27
38
49
5
11
12
13
14
1510
171618
19
CN206DB15
R537 1K 1/10W 5%
C256
0.22uF
D3V3
2 4
5
3SN74LVC1G17DBVRU209
C255
0.1uF/16V
VGA_R
VGA_HSYNC
C259
NC/22pF
VGA_VSYNC
C257
NC/22pF
VGA_SDA
VGA_B
VGA_SCL
R539
NC/4K7 1/10W 5%
VCC5D
R272
4K7 1/10W 5%
R287 NC/10K 1/10W 5%
3V3_STB
+5VSB
R271
4K7 1/10W 5%
VGA_G 4
VGA_R 4
VGA_B 4
C261
0.1uF/16V
2 4
5
3SN74LVC1G17DBVRU211
3V3_STB
EDID_WP
D3V3
3
1 2
ZD204
BAT54C
1 2ZD203
VPORT0603100KV05
RGB_HSYNC
UART0_TX7
R274
NC/100R 1/10W 5%
R273
NC/10K 1/10W 5%
R254 220R 1/10W 5%
1 2FB507120OHM
49
07) SIO I/F
R4D7
10K 1/10W 5%
VCC5D
USB2_DNUSB2_DP
SPI_CS_N
C410
4.7uF 25V
3V3_STB
EJTAG_RSTN
SPI_HOLD
TRSTN
SPI_CLK
D3V3
MOR_RSTN
D3V3
C409
30PF50V
C411
4.7uF 25V
D3V3
C413
0.1uF/16V
R433 47R 1/10W 5%
R434 47R 1/10W 5%
C4D9
NC
C4E3
NC
C408
30PF50V
SPI_WEN8
R414
10K 1/10W 5%
USB_EN_N
1234567891011121314
CN401
NC
USB_OC_N
R402
NC/33R 1/10W 5%
R448 4K7 1/10W 5%
EJTCK
R439 100R 1/10W 5%
R437 100R 1/10W 5%
KEY_IR
UART0_TX 6UART0_RX 6
R418 NC/4K7 1/10W 5%
R441
1M 1/10W 5%
R443 10K 1/10W 5%
X401 25MHz
C405 0.1uF 16V
C4F6 0.001uF
88G 352 21CL
USBPort
D3V3
USB_OC_N 8USB_EN_N8
SW401
NC/TACT SW FWRD H1.5MM
GND1 IN2 IN3 EN(EN)4
OC5
NC6
OUT 7
OUT8
U408
G545B2RD1U
SPI_WEN
I/O11GND 2I/O23
I/O34
VDD5
I/O46
U402NC/AZC099-04S
3V3_STB
1234
65
12
34
CN402CONNNECTOR
D3V3
EJTDIEJTDOEJTMS
R445 6.04 K OHM 1% 1/10W
GND1
RESET2VCC
4
MR3
U412
G692L293TCUf 2.91V
R440 10K 1/10W 5%
R4D5
100K 1/10W 5%
RESET_N
RESET_N
R411 NC/33R 1/10W 5%
R413 33R 1/10W 5%R412 NC/33R 1/10W 5%
TDI_MTDO_M
3PX2 S/T 2.0mm
R425 2K2 1/10W 5%
1
2
4
3L401
90 ohm
12
ZD401
NC/VPORT0603100KV05
3
2
1
4
5
6
NC/CONNCN406
R427 2K2 1/10W 5%
Run As 90 Ohm +/-15%Differential Pairs
R417 33R 1/10W 5%
R431 47R 1/10W 5%
R406
1K 1/10W 5%
R416 33R 1/10W 5%
F401 NC/FUSE
R408
NC/4K7 1/10W 5%
R429
4K7 1/10W 5%
U404 should be programmedbefore soldering on PCB
C406
0.1uF/16V
R407
1K 1/10W 5%
VCC5D
R409
4K7 1/10W 5%
R420 4K7 1/10W 5%
HOLD1
Vcc2
NC13
NC24
NC35
NC46
S7
Q8
W9
GND 10
NC5 11
NC612
NC713
NC814
D15
C16
SPI FLASH32M bit
U404
MX25L3205DMI-12G
3
12
U407
RClamp0520B.TCT
Crystal X40135ppm 20 50ppm 0~70
R442
499R 1/10W 1%
R428 4K7 1/10W 5%
UART0_RX
UART0_TX
KEY_IR
R432 47R 1/10W 5%
R422
NC/47R 1/10W 5%
R430 47R 1/10W 5%
I2C1_SCLI2C1_SDA
R410 33R 1/10W 5%
R404
1K 1/10W 5%
+5VSB
R405
4K7 1/10W 5%
D3V3
D3V3
D3V3
VCC5D
I2C1_SDA 3,5I2C1_SCL 3,5
KEY_IR 8
R424 2K2 1/10W 5%R423 2K2 1/10W 5%
R401
4K7 1/10W 5%
USB5V
I2C2_SDAI2C2_SCL
R436
10K 1/10W 5%
I2C0_SCL I2C0_SDA
C404
0.22uF
EEPROM_WP1
D3V3
I2C0_SCLE0
1
E1 2
E23
VSS4
SDA5 SCL6 WC7 VCC8
U405
M24C64-WMN6P
EJTAG I/F
USB5V
HEADER 2X7P S/T 2.5mm
3V3_STB
System MCU RESET
I2C0_SDA
SPI_WRSPI_RD
R435
4K7 1/10W 5%
R415 33R 1/10W 5%
UART0_RXUART0_TX
0402 C412 0.1uF 16V0402
TRSTE16
TDI_TE14
TDO_T E18
TMSE15
TCKE17
TAPSEL E13
IRRR22
UART0_TXL22
UART0_RXM22
UART1_TXP22
UART1_RXN22
I2C0_CAC16
I2C0_DAC17
I2C1_CAC18
I2C1_DAC19
TV_I2C2_CAC20
TV_I2C2_DAC21
I2C_MORPH__ENA AC22
SPI_DIAC25SPI_DOAB24
SPI_CLKAB25
SPI_SEL0AC24
SPI_SEL1 AC26
SPI_HOLDAB26
RESET_NW26
CLKIN_25MN1
CLKOUT_25MN2
TAPSEL_CASD13
TDI_ME19
TRIN_RESET_NAD7
MOR_RESET_N AB22
MOR_RESET_N_OUTAB21
TDO_MB25
USB_PADNAB12
USB_PADP AC12
USB2_DNAF26
USB2_DPAE26
USB2_REXTAD26
USB2_ATEST AD25
CLKIN_24M U26
CLKOUT_24MU25
CLKIN_SELAF3
SIO I/F
JTAG/EJTAG
UART
I2C
SPI
USB
U401C
ZR39775HGCF-BD
EEPROM_WP18
RESET_N
50
08) GPIO Block
USB_OC_N
R472
10K 1/10W 5%
C416
0.01uF
HDMISW_RSTN
AUD_SHDN 12PWR_ON 14
R463 33R 1/10W 5%
GPIO_P21 U24
GPIO_P22 U23
GPIO_P23 R23
GPIO_P25 AB14GPIO_P24 AB13
GPIO_P3D10
GPIO_P4D11
GPIO_P5D12
GPIO_P6E12
GPIO_P7E11
GPIO_P8AB20
GPIO_P9AB19
GPIO_P10AB18
GPIO_P11AB17
GPIO_P1C11
GPIO_P2C12
GPIO_P0C10
GPIO_P26 AB16
GPIO_P27 AC14
GPIO_P19D5
GPIO_P13C6
Res_AA6 AA6
GPIOBOOT_STRAP0BOOT_STRAP1BOOT_STRAP2BOOT_STRAP3
8051_BOOT
U401K
ZR39775HGCF-BD
C415
1uF/25V
R462 33R 1/10W 5%
C429
0.1uF 16V
+C430 100uF/16V
R473 4R7 1/10W 5%
AFE_CLK K4
AFE_TEST0 AB10
AFE_TEST1 AB9
AFE_TEST2 AB8
AFE_TCLK_IN U6
AFE_TCLK_OUT V6
AFE_XCLK_TEST AB7
AFE_ATCLK0 M6
AFE_ATCLK1 N6AFE_XCLK AE3
AFE I/F_GPO
U401S
ZR39775HGCF-BD
KEY_IR
C425
4.7uF/10V
C426
0.1uF 16V
C427
0.001uFVID0 E1
VID1 E2
VID2 E3
VID3 E4
VID4 E5
VID5 F1
VID6 F2
VID7 F3
Vsy nc_in F4
Hsy nc_in F5
VCLKx2 G3
TEST_G11 G4
TEST_G12 H3
TVMM I/F
U401M
ZR39775HGCF-BD
TEST_MODE
0
BOOT_STRAP2
AVDD18_HPLL L3AVDD3_HPLL M4
AVDD3_SYNC N3
AVDD3_SYNC1 R3
AVDD3_AFE N4
AVDD18_R P2
AVDD18_G P1
AVDD18_B R1
LVDSVCTX_VDD33_0G5
LVDSVCTX_VDD33_1G6
LVDSVCTX_REXTG1LVDSVCRX_REXTG2
PGA_LDO0P4
AFE_AVSSY3
LVDSVCRX_VDD33_0H6
LVDSVCRX_VDD33_1J6
DVDD18 R4
DM_PLL_VDD AB2
IF_VDD3P3_0 AC1
IF_VDD3P3_1 AC2
AVDD18_SVIDEO R2
AVDD18_CVBS P3
ADC8_RBIASAC3
ADC8_VREFAC4
ADC8_INAAC5
ADC8_INBAD6
ADC8_INCAD5
ADC8_INDAD4
ADC8_INEAE5
ADC8_INFAE6
VDD33_BODAB5 AFE_AVSS0 W4
AFE_AVSS1 W5
AFE_AVSS2 W6
VDDADC8 AF5
RC_OSC_REXTAF6
AFE_AVSS3 Y4
AFE_AVSS4 Y5
AFE_AVSS5 Y6
ACOD3_AVDD AE10
ACOD3_AVSS AE11
AVSS_HPLL M3
LVDSVCRX_ATSTL6
LVDSVCTX_ATSTK6
ADC8_INGAB6
AFE_AVSS6 L7
AFE_AVSS7 M7
AFE_AVSS8 N7
AFE_AVSS9 P7
AFE_AVSS10 U7
U401Q
ZR39775HGCF-BD
BOOT_STRAP1
R486 51K 1/10W 5%
SPI_WEN
BOOT_STRAP0
BOOT_STRAP3
R491 100R 1/10W 1%
1
BOOT2
0
D3V3
C431
1uF/25V
R467
1K 1/10W 5%
C432
0.1uF 16V
R468 1K 1/10W 5%
3V3_CHECK
1
1
I2C EEPROM
3V3_STB
BOOT3
0402
1
3V3_STB
USB_OC_N 7
3V3_STB
1
1V8_STB
C433
0.01uF
1
C434
4.7uF/10V
R447 NC/33R 1/10W 5%
TVMicro BootstrapConfiguration
01
16-Bit NAND-Small Page
0
TVM_BOOT
PANEL_PWR_CHECK
0402
0402
BOOT0
0402
SPI
Boot Option
1
R487
10K 1/10W 1%R489 100R 1/10W 1%
Debug Mode
1
VGA_VSYNC_DET
1
BOOT1
0402
Normal Mode
VGA_HSYNC_DET VGA_HSYNC_DET 6VGA_VSYNC_DET 6VGA_VSYNC_DET
C4E8
0.001uF
KEY_IR 7
C4F2
0.001uF
LIGHT_SENSOR
State
8-Bit NAND-Large Page
1
33G380210B Y
3
1 2
ZD402
BAT54C
0402
TEST MPDE
Bootstrap Configuration
1V8_STB
01
1 2
FB423
120OHM
Boot Option
10P S/T 2.0mm
3V3_STB0402
3V3_STB
3V3_STB
C4F8
0.01uF
1
1
8-Bit NAND-Small Page
0
SPI
D3V3
A_GND
LED_B
C4F5
0.001uF
LED_R1 2FB421 300 OHM1 2FB422 300 OHM
R484 3K3 1/10W 5%
PANEL_ON 10,15
BL_ON_OFF 14
Q402MMBT3904
R480
470R 1/10W 5%VDD33-BOD
C4F9
NC/1uF/16V
R481
470R 1/10W 5%
HDMISW_RSTN 5
3V3_STB
LIGHT_SENSOR
Q403MMBT3906
R453 4K7 1/10W 5%
LED_R
R454 4K7 1/10W 5%
LED_B
R458 4K7 1/10W 5%
C4E4
0.01uF
TEST_MODE
R456
NC/4K7 1/10W 5%
USB_EN_N USB_EN_N 7
3V3_STB
BL_ON_OFF
1 2FB419 300 OHM
R485 3K3 1/10W 5%LED_2
KEY_INKEY_PWR
1 2FB420 NC/300 OHM
C4F3
0.001uF
LED_1
C4E6
0.01uF
C4F4
0.001uF
LED_2
C4E7
0.01uF
LED_1
R466 0R05 1/10W 5%
I/O11GND2I/O23
I/O34
VDD5
I/O46
U409AZC099-04S
C428
4.7uF/10V
R455 33R 1/10W 5% SPI_WEN 7
BOOT_STRAP3R452
NC/10K 1/10W 5%
BOOT_STRAP2
3V3_STB
PANEL_PWR_CHECK
R479 1K 1/10W 5%
PANEL_POWER
R469
4K7 1/10W 5%
TVM_BOOT
VGA_HSYNC_DET
EARPHONE_DET
12345678910
CN403
CONN
C414
10uF/6.3V
3V3_STB
R460
10K 1/10W 5%
C407
1uF/25V
KEY_PWR
R419 33R 1/10W 5%
1 2
FB424
120OHM
D3V3
R403 100R 1/10W 5%
PANEL_ON
12
CN409
NC/CONN
3V3_STB
1 2
FB403
120OHM
AUD_AMP_MUTE
C420
4.7uF/10V
1 2
FB404
120OHM
D3V3
VCC1V1
ADC 0.4V~2.9V
R450
4K7 1/10W 5%
D1V8
TVM_BOOT
C423
1uF/25V
C424
0.1uF 16V
C421
1uF/25V
C422
0.1uF 16V
C418
10uF/6.3V
R490
3K9 1/10W 1%
AV2_S_DET
BOOT_STRAP1
C4E5 10uF/6.3V
PANEL_CTRL2 3,10PANEL_CTRL2
AUD_AMP_MUTE 12
C441
0.1uF/16V
C439
1uF/25V
C440
0.1uF 16V
1 2
FB409
120OHMC438
22pF
AV2_S_DET 4
EEPROM_WP1
C419
0.1uF 16V
BOOT_STRAP0
C437 0.1uF 16V
R470 845R 1/10W 1%
C436
0.1uF 16V
C435
1uF/25V
R451
4K7 1/10W 5%
R471 845R 1/10W 1%
R488 9.1KOHM +-1% 1/10W
KEY_IN
1 2FB410 120 OHM
3V3_STB
1V8_STB
3V3_STB
3V3_CHECK
PWR_ON
EARPHONE_DET 13
DEMOD_RSTN 3
R459 4K7 1/10W 5%
1 2
FB401
120OHM
AUD_SHDN
1 2
FB405
80OHM
1 2
FB407
120OHM
R477 NC/0R05 1/10W 5%R478 NC/0R05 1/10W 5%
1 2
FB408
120OHM
C417
0.001uF
VGA_VSYNC_DET 6
VGA_HSYNC_DET 6
1 2FB406 300 OHM
R457 33R 1/10W 5%
R461 33R 1/10W 5%
R482 1K 1/10W 5%R483 1K 1/10W 5%
EEPROM_WP1 7
51
09) DDRII SDRAM I/F
S0_LDQSNS0_LDQS
S0_DQ2
C457
NC/0.1UF16V
C458
NC/0.1UF16V
C444
0.1uF/16V
R495
60.4 OHM 1% 1/10W
R496
60.4 OHM 1% 1/10W
C459
NC/0.1UF16V
D1V8
C443
0.1uF/16V
C455
NC/0.1UF16V
C451
0.1uF/16V
C460
NC/1uF/16V
C456
NC/0.1UF16V
D1V8
D1V8 D1V8
D1V8
D1V8
D1V8
D1V8
S0_DQ3
S0_DQ5S0_DQ4
S0_CASN
S0_LDM
S0_CKES0_RASN
S0_UDM
S0_CKS0_CKN
S0_WENS0_ODT
S0_CKNS0_CK
S0_DQ7S0_DQ8
S0_DQ6
S0_DQ10S0_DQ11
S0_DQ9
D1V8
C453
NC/0.1uF/16V
C452
NC/0.1uF/16V
S0_DQ13S0_DQ14
S0_DQ12
S0_DQ15
C461
NC/0.1uF/16V
C454
NC/0.1uF/16V
R4A3
NC/100R 1/10W 5%
C401
0.01uF
R499
NC/100R 1/10W 1%
S1_BA0
S1_DQ0
S1_DQ2
S1_A8
S1_VREF
S1_BA2
S1_DQ8S1_A11S1_A10
S1_DQ14
S1_A1
R4A1
NC/100R 1/10W 1%
S1_DQ9
S1_DQ12
S0_A[0:12]
S1_A0
S1_A3
S1_DQ6
S1_A4 S1_DQ1
S1_DQ15
C402
0.01uF
S1_A5
S1_A9
S1_A7
S1_A2
S1_DQ13
S1_DQ10
S1_DQ5
S1_DQ7
S1_A12
S1_A6 S1_DQ3
S1_DQ11
S0_DQ15B15
S0_DQ14A21
S0_DQ13A14
S0_DQ12B22
S0_DQ11B20
S0_DQ10B17
S0_DQ9B21
S0_DQ8A15
S0_DQ7B14
S0_DQ6A22
S0_DQ5B13
S0_DQ4A23
S0_DQ3B19
S0_DQ2A18
S0_DQ1B23
S0_DQ0A13
S0_UDMA20
S0_LDMA19
S0_VREFA24
S0_A13C14
S0_A12 C24
S0_A11C18
S0_A10D22
S0_A9 D18
S0_A8D14
S0_A7D23
S0_A6 D17
S0_A5C19
S0_A4 C15
S0_A3C23
S0_A2C17
S0_A1 D19
S0_A0D15
S0_BA2C22
S0_BA1 C20
S0_BA0D21
S0_UDQS_N A16
S0_UDQS_PB16
S0_LDQS_N B18
S0_LDQS_PA17
S0_RAS_N D16
S0_CAS_NC16
S0_WE_ND20
S0_CK_NB12
S0_CK_PA12
S0_CKE C21
S0_ODT C13RDRIVERB26
RDRIVER50A26
RTERMA25
S0 Memory I/F
U401A
ZR39775HGCF-BD
S1_DQ4
S1_BA1
S1_VREFS1_DQ15F25
S1_DQ14M26
S1_DQ13E26
S1_DQ12N25
S1_DQ11L25
S1_DQ10H25
S1_DQ9M25
S1_DQ8F26
S1_DQ7E25
S1_DQ6N26
S1_DQ5D25
S1_DQ4P26
S1_DQ3K25
S1_DQ2J26
S1_DQ1P25
S1_DQ0D26
S1_UDML26
S1_LDMK26
S1_VREFR26
S1_ODTD24
S1_CK_N C25
S1_CK_PC26
S1_CKEM24
S1_RAS_NG23
S1_CAS_NG24
S1_WE_N L23
S1_UDQS_NG26
S1_UDQS_P G25
S1_LDQS_NJ25
S1_LDQS_PH26
S1_A13 E24
S1_A12R24
S1_A11J24
S1_A10 N23
S1_A9J23
S1_A8 E23
S1_A7P23
S1_A6H23
S1_A5 K24
S1_A4F24
S1_A3P24
S1_A2 H24
S1_A1K23
S1_A0F23
S1_BA2 N24
S1_BA1L24
S1_BA0 M23
S1 Memory I/F
U401B
ZR39775HGCF-BD
S0_VREF
S1_UDQS
S1_LDQSN
S1_UDQSNS1_LDQS
C4G3
0.01uF
040204020402
S0_A2
S0_A0S0_A1
S0_A3
S0_UDQS
S0_BA2
S0_A5
S0_BA0S0_BA1
R494
0R05 1/10W 5%
256Mb (16Mx16) DDRII56G 615 75HY5PS561621BFP-2556G 615 66NANYANT5TU16M16AG-25D
512Mb (32Mx16) DDRII56G 615 76H5PS5162FFR-25C56G 615 67NANYANT5TU32M16CG-25C
S0_A4
S0_UDQSN
S0_VREF
S1_CASNS1_RASN
R4A2
NC/0R05 1/10W 5%
S1_VREF
S0_DQ10
S1_CK S1_ODT
S1_UDMS1_LDM
S1_CK
S1_LDQS
S1_CKE
S1_CKN
S1_CKE
S1_CKN
S1_RASN
S1_LDQSN
S1_WEN
S1_UDQSN
S1_CK
S1_WENS1_CASN
S1_ODT
S1_CKN
S1_UDQS
S1_DQ9
S1_DQ12
S1_DQ[0:15]
S1_LDM
S1_DQ6
S1_UDM
S1_DQ13
S1_DQ2
S0_DQ[0:15]
S0_A3
S1_DQ10
S1_DQ3
S0_A5
S1_DQ14
S0_A1S0_A11
S0_A4
S0_A6
S0_A0
S0_A2
S1_DQ7
S0_A7
S0_A12
S0_A11
S0_A8
S1_DQ15
S0_A12
S0_A9S0_A10
S0_A10
S1_DQ1
S1_DQ4S1_DQ5
S1_DQ0
S1_DQ8
S1_DQ11
0402
C4G4
0.01uF
0402
S0_UDM
0402
S0_BA0
S1_A2S1_A1
S0_A6
S1_A8
S0_A8
S0_BA1S0_BA2
S1_A10
S0_A9
S1_A4
S0_A7
S1_A0
0402
S1_BA1
S1_A12
S1_A9
S1_A5
0402
S1_BA2
S1_A11
S1_BA0
S1_A7S1_A6
S1_A3
S0_DQ13
S0_DQ15
S0_DQ12S0_DQ11
S0_LDM
S0_DQ8S0_DQ9
S0_DQ14
S0_DQ2S0_DQ3S0_DQ4S0_DQ5
0402
S0_DQ1
S0_A[0:12]
0402
C4G5
0.01uF
S0_DQ7S0_DQ6
S0_ODT
S0_LDQSS0_LDQSN
S0_RASNS0_CASNS0_WEN
S0_CKNS0_CKS0_CKE
S0_DQ0
C403
0.01uF
C4F7
NC
C449
0.1uF 16V
A0M8
A1M3
A2M7
A3N2
A4N8
A5N3
A6N7
A7P2
A8P8
A9P3
A10M2
A11P7
BA0L2
BA1L3
LDMF3 UDMB3
VREFJ2
CKEK2
CKJ8
CK#K8
CSL8
RASK7
CASL7
WEK3 NC A2
DQ0G8
DQ1 G2
DQ2H7
DQ3H3
DQ4 H1
DQ5H9
DQ6F1
DQ7 F9
DQ8C8
DQ9C2
DQ10 D7
DQ11D3
DQ12 D1
DQ13D9
DQ14B1
DQ15 B9
LDQSF7
UDQS B7
A12R2
VS
SA
3
VS
SQA
7
VD
DA
1
VD
DE
1
VD
DJ9
VDD
QC
1
VD
DM
9
VD
DR
1
VDD
LJ1
VDD
QA
9
VDD
QC
3
VDD
QC
7
VDD
QC
9
VDD
QE
9
VDD
QG
1
VDD
QG
3
VDD
QG
7
VDD
QG
9
VS
SE
3
VS
SJ3
VS
SN
1
VS
SP
9
VS
SDL
J7
VS
SQB
2
VS
SQB
8
VS
SQD
2
VS
SQD
8
VS
SQE
7
VS
SQF
2
VS
SQF
8
VS
SQH
2
VS
SQH
8
NCL1
ODTK9
NCR3
NCR7
UDQSA8
LDQS E8
NCE2
NCR8
U411
NC/HY5PS561621BFP-25
C450
1uF/25V
C4E2
0.01uF
S0_VREFS0_A13
S0_A13
S1_A13
C4E9
10uF 16V
C4F1
NC/10UF16V
R497
150R 1/10W 1%
A0M8
A1M3
A2M7
A3N2
A4N8
A5N3
A6N7
A7P2
A8P8
A9P3
A10M2
A11P7
BA0L2
BA1L3
LDMF3 UDMB3
VREF J2
CKEK2
CKJ8
CK#K8
CSL8
RASK7
CASL7
WEK3
NCA2
DQ0 G8
DQ1G2
DQ2H7
DQ3 H3
DQ4H1
DQ5 H9
DQ6F1
DQ7F9
DQ8 C8
DQ9C2
DQ10D7
DQ11 D3
DQ12D1
DQ13D9
DQ14 B1
DQ15B9
LDQSF7
UDQSB7
A12R2
VSS
A3
VSS
QA
7
VDD
A1
VDD
E1
VDD
J9
VD
DQ
C1
VDD
M9
VDD
R1
VD
DL
J1
VD
DQ
A9
VD
DQ
C3
VD
DQ
C7
VD
DQ
C9
VD
DQ
E9
VD
DQ
G1
VD
DQ
G3
VD
DQ
G7
VD
DQ
G9
VSS
E3
VSS
J3
VSS
N1
VSS
P9
VSS
DL
J7
VSS
QB
2
VSS
QB
8
VSS
QD
2
VSS
QD
8
VSS
QE
7
VSS
QF
2
VSS
QF
8
VSS
QH
2
VSS
QH
8
NCL1
ODTK9
NCR3
NCR7
UDQS A8
LDQSE8
NCE2
NC R8
U410
H5PS5162FFR-S6CS0_UDQS
R498
100R 1/10W 5%
C447
0.1uF 16V
S1_A13
C446
0.1uF 16V
S0_DQ0
S0_UDQSN
R492
100R 1/10W 1%
C445
0.1uF 16V
C442
0.1uF/16V
R493
100R 1/10W 1%S0_DQ1
C448
0.1uF 16V
52
10) LVDS I/F
0402
0402
Place parts veryclose to U401
0402
D402 NC/LL4148
+ C486
22uF/25V
0402
1 2
FB412
120OHM
0402R4C5
0R05 1/10W 5%
0402
C498
0.47UF10V
BL_PWM_CTRL
C472
0.1uF 16V
PANEL_CTRL23,8
C4D7
1uF/25V
C476
0.1uF 16V
C470
0.1uF 16V
C4B3
0.1uF 16V
C467
0.1uF 16V
C462
0.1uF 16V
R4B9
47K 1/10W 5%
C4B6
0.1uF 16V
C496
0.47UF10V
C468
0.1uF 16V
C497
1uF/25V
R4B5
47K 1/10W 5%
C480
0.1uF 16V
R4B6
100K 1/10W 5%
C494
0.01uF
C463
0.1uF 16V
C4B2
0.1uF 16V
C471
0.1uF 16V
C489
0.01uF
C4B1
0.1uF 16V
PANEL_CTRL1 4
C4A9
0.1uF 16V
C4D4
0.1uF 16V
C464
0.1uF 16V
C4A2
1uF/25V
C4D1
0.1uF 16V
C4B5
0.1uF 16V
C466
0.1uF 16V
C479
0.1uF 16V
C4A1
0.47UF10V
C4D3
0.1uF 16V
R4A7
NC/1K 1/10W 5%
C469
0.1uF 16V
S1
S2
S3
G4
D 8
D7
D 6
D 5
Q404
AO4449 -7A/-30V
C4B8
0.47uF/16V
C465
0.1uF 16V
C4C9
0.1uF 16V
C4C1
0.1uF 16V
R4B3
NC/0R05 1/4W 5%
R4B8
10K 1/10W 5%
HDMI_3V3
R4A9 1K 1/10W 5%
C4B4
0.1uF 16V
D1V8
Q405MMBT3904
1 2
FB416
NC/120OHM
1 2
FB415
120OHM
R4A8 820R 1/10WR 5%
C4B7
0.1uF 16V
C474
10uF 16V
R4B4
0R05 1/4W 5%
C481
0.1uF 16V
C493
0.1uF 16V
C482
0.1uF 16V
C473
1uF/25V
C483
1uF/25V
C478
0.1uF 16V
VCC1V1
C4D2
0.1uF 16V
C484
10uF 16V
C4D6
1uF/25V
C4B9
0.1uF/16V
C477
0.1uF 16V
P12V
PANEL_POWER
PANEL_5V
D1V8
VCC1V1
D3V3
D1V8
VCC1V1
D3V3
VCC1V1
D3V3
PANEL_ON8,15
BL_BR_CTRL 14
1 2
FB411
300 OHM
D3V3
3V3_STB
1V8_STB
1 TP7
C492
1uF/25V
24681012141618202224
13579
11131517192123
CN405CONN
R4A5
NC/1K 1/10W 5%
PWM1 AB23
LVDS_CE_P AF24
LVDS_CE_N AE24
LVDS_CO_P AE19
LVDS_CO_N AF19
LVDS_D0E_P AD23
LVDS_D0E_N AD24
LVDS_D1E_P AE23
LVDS_D1E_N AF23
LVDS_D2E_PAF22
LVDS_D2E_N AE22
LVDS_D3E_P AD21
LVDS_D3E_NAD22
LVDS_D4E_P AE21
LVDS_D4E_N AF21
LVDS_D5E_P AF20
LVDS_D5E_N AE20
LVDS_D0O_P AF18
LVDS_D0O_N AE18
LVDS_D1O_P AD17
LVDS_D1O_N AD18
LVDS_D2O_P AE17
LVDS_D2O_N AF17
LVDS_D3O_PAF16
LVDS_D3O_N AE16
LVDS_REXT AD20LVDS_TXATST AD19
LVDS_D4O_P AD15
LVDS_D4O_NAD16
LVDS_D5O_P AE15
LVDS_D5O_N AF15
PWM2 AC23
LVDS I/F
U401J
ZR39775HGCF-BD
D3V3
BL_PWM_CTRL
C4A5
0.1uF 16V
PANEL_POWER
C4C3
1uF/25V
C495
0.001uF
D3V3
USB_VDD1AC11
USB_VDD33 AC13
PLL_VDD33 V26
CORE_VDD18_STBY1 P6
CORE_VDD18_STBY2R6
LDI_VDD33_0 AC15
LDI_VDD33_1 AB15
CORE_VDD18_STBY3 T6
CORE_VDD52AA7
USB2_VDD33 AF25
CORE_VDD0F11
CORE_VDD1F12
CORE_VDD2F13
CORE_VDD3F14
CORE_VDD4F15
HDMI_VDD3P3_0E7
HDMI_VDD3P3_1E8
HDMI_VDD3P3_2F7
HDMI_VDD3P3_3F8
HDMI_VDD1V_0E9
HDMI_VDD1V_1E10
HDMI_VDD1V_2F9
HDMI_VDD1V_3F10
CORE_VDD5G12
CORE_VDD6G13
CORE_VDD7G14
CORE_VDD8G15
CORE_VDD9G16
CORE_VDD10L20
CORE_VDD11L21
CORE_VDD12M20
CORE_VDD13M21
CORE_VDD14N20
CORE_VDD15N21
CORE_VDD16P20
CORE_VDD17P21
CORE_VDD18R20
CORE_VDD19R21
CORE_VDD20T20
CORE_VDD21T21
CORE_VDD22T22
CORE_VDD23T23
CORE_VDD24T24
CORE_VDD25U20
CORE_VDD26U21
CORE_VDD27V20
CORE_VDD28V21
CORE_VDD29W20
CORE_VDD30W21
CORE_VDD31V7
CORE_VDD32W7
CORE_VDD42AA8
CORE_VDD43AA9
CORE_VDD44AA10
CORE_VDD45AA11
CORE_VDD46AA12
CORE_VDD47AA13
CORE_VDD48AA14
CORE_VDD49AA15
CORE_VDD18_STBY0 P5
IO_VDD0 G7
IO_VDD1 G8
IO_VDD2 G9
IO_VDD3 G10
IO_VDD4 G11
IO_VDD5 H7
IO_VDD6 H8
IO_VDD7 J7
IO_VDD8 Y16
IO_VDD9 Y17
IO_VDD10 Y18
IO_VDD11Y19
IO_VDD12 Y20
IO_VDD13 Y21
IO_VDD14 AA16
IO_VDD15AA17
IO_VDD16 AA18
IO_VDD17 AA19
IO_VDD18 AA20
IO_VDD19AA21
IO_VDD20 AA22
IO_VDD21 AA23
IO_VDD22 AA24
IOVDD_STBY0 H4
IOVDD_STBY1 J4
CORE_VDD50T25
CORE_VDD51T26
M_VDD0 E20
M_VDD1 E21
M_VDD2 E22
M_VDD3 F16
M_VDD4 F17
M_VDD5F18
M_VDD6 F19
M_VDD7 F20
M_VDD8 F21
M_VDD9F22
M_VDD10 G17
M_VDD11 G18
M_VDD12 G19
M_VDD13G20
M_VDD14 G21
M_VDD15 G22
M_VDD16 H20
M_VDD17 H21
M_VDD18 H22
M_VDD19 J20
M_VDD20 J21
M_VDD21 J22
M_VDD22 K20
M_VDD23 K21
CORE_VDD33Y7
CORE_VDD34Y8
CORE_VDD35Y9
CORE_VDD36Y10
CORE_VDD37Y11
CORE_VDD38Y12
CORE_VDD39Y13
CORE_VDD40Y14
CORE_VDD41Y15
IO_VDD23 AA25
IO_VDD24 AA26
IOVDD_STBY2 H5
IOVDD_STBY3 J5
IOVDD_STBY4K7
CORE_VDD18_STBY5 R7CORE_VDD18_STBY4 T7
Power
STBY
POWER
U401R
ZR39775HGCF-BD
246810121416
13579
111315
CN404NC/CONN
C4A7
0.1uF 16V
C4A8
0.1uF 16V
VCC1V1
PANEL_ON
1 2
FB413
120OHM
R4C3 NC/0R05 1/10W 5%
3V3_STB
C4A4
0.1uF 16V
C4C4
0.1uF 16V
C4C5
0.1uF 16V
C4C6
1uF/25V
1
2
4
3L402 NC/90 ohm
1V8_STB
GND51 P11GND50 P10GND49 P9GND48N18
GND47N17
GND46N16
GND45N15
GND44N14
GND43N13
GND42N12
GND41N11
GND40N10
GND39N9
GND38M18
GND37M17
GND36M16
GND35M15
GND34M14
GND33M13
GND32M12
GND31M11
GND30M10
GND29M9
GND28L18
GND27L17
GND26L16
GND25L15
GND24L14
GND23L13
GND22L12
GND21L11
GND20L10
GND19L9
GND18K18
GND17K17
GND16K16
GND15K15
GND14K14
GND13K13
GND12K12
GND11K11
GND10K10
GND9K9
GND8J18
GND7J17
GND6J16
GND5J15
GND4J14
GND3J13
GND2J12
GND1J11
GND0J10
GND52 P12
GND53 P13
GND54 P14
GND55 P15
GND56 P16
GND57 P17
GND58 P18
GND59 R9
GND60 R10
GND61R11
GND62 R12
GND63 R13
GND64 R14
GND65R15
GND66 R16
GND67 R17
GND68 R18
GND69T9
GND70 T10
GND71 T11
GND72 T12
GND73 T13
GND74 T14
GND75 T15
GND76 T16
GND77 T17
GND78 T18
GND79 U9
GND80 U10
GND81 U11
GND82U12
GND83 U13
GND84 U14
GND85 U15
GND86U16
GND87 U17
GND88 U18
GND89 V9
GND90V10
GND91 V11
GND92 V12
GND93 V13
GND94 V14
GND95 V15
GND96 V16
GND97 V17
GND98 V18
GND100 F6GND99 B24
USB2_GNDAE25
PLL_VSSV25
S1_GND R25
Ground
U401N
ZR39775HGCF-BD
C4D8
10uF 16V
C4A6
0.1uF 16V
LVDS_CKO_N
LVDS_CKE_N
LVDS_CKE_P
C4D5
0.001uF
C4C8
0.1uF 16V
1
2
4
3L403 NC/90 ohm
1 2
FB418
120OHM
LVDS_CKO_P
C4C7
0.1uF 16V
1
2
4
3L404 NC/90 ohm
LVDS_D0E_P
LVDS_D0E_N
1
2
4
3L405 NC/90 ohm
LVDS_D1E_P
LVDS_D1E_N
1
2
4
3L406 NC/90 ohm
LVDS_D2E_P
LVDS_D2E_N
1
2
4
3L407 NC/90 ohm
LVDS_D3E_N
LVDS_D3E_P
1
2
4
3L409 NC/90 ohm
LVDS_D0O_P
LVDS_D0O_N
LVDS_D4E_P
1
2
4
3L410 NC/90 ohm
1
2
4
3L408 NC/90 ohm
LVDS_D4E_N
LVDS_D1O_P
LVDS_D1O_N
1
2
4
3L411 NC/90 ohm
LVDS_D2O_N
LVDS_D2O_P
1
2
4
3L412 NC/90 ohm
LVDS_D3O_P
LVDS_D3O_N
1 2
FB417
120OHM
LVDS_D4O_P
1
2
4
3L413 NC/90 ohm
LVDS_D4O_N
C488
0.001uF
1 2
FB414
120OHM
C487
0.1uF/16V
LVDS_D3E_N
LVDS_D0E_N
LVDS_D2O_PLVDS_D1O_P
LVDS_CKO_N
LVDS_CKE_P
LVDS_D2E_P
LVDS_D3O_PLVDS_D3O_N
LVDS_D0E_P
LVDS_D2O_N
LVDS_D3E_P
LVDS_D1O_NLVDS_D0O_N
LVDS_D1E_NLVDS_D2E_N
LVDS_D1E_P
LVDS_CKO_P
LVDS_CKE_N
LVDS_D0O_P
BL_BR_CTRLR4C2 0R05 1/10W 5%
BL_BR_CTRL
C499
1uF/25VC4A3
1uF/25V
C491
0.1uF 16V
C490
1uF/25V
C4C2
0.1uF 16V
D3V3
LVDS_D4E_N LVDS_D4E_P
LVDS_D4O_N LVDS_D4O_P
04020402
0402
0402
R4D6
4K7 1/10W 5%
0402
0402
04020402
8PX2 S/T 2.0mm
0402
33G8027 24
0402
33G8027 16
0402
0402
04020402
D3V3
0402
0402
C4E1
0.1uF/16V0402
R4B7
1K 1/10W 5%
0402
R4A6
NC/1K 1/10W 5%
0402
D3V3
R4A4
NC/1K 1/10W 5%
0402
0402
0402
0402
0402
0402
0402
0402
For 32' Sharp Panel,R4A7 from NC to 1K
0402
0402
0402
0402
0402
0402
12PX2 S/T 2.0mm
0402
0402
0402 04020402
0402
0402
0402
53
11) Audio Inputs
FB601 0R05 1/10W 5%
FB602 0R05 1/10W 5%
12
ZD604
VPORT0603100KV05
FB603 0R05 1/10W 5%
FB604 0R05 1/10W 5%
R615 10K 1/10W 5%
FB605 0R05 1/10W 5%
FB606 0R05 1/10W 5%
1 2FB607 300 OHM
AV1_Audio_L
12
ZD603
VPORT0603100KV05
YPbPr2_Audio_R
YPbPr2_Audio_L
R618
10K 1/10W 5%
PC_Audio_L
PC_Audio_R
AV1_Audio_R
AV2_Audio_LAV2_Audio_R
R624
10K 1/10W 5%
C615
100pF
C616
100pFR625
10K 1/10W 5%
12
ZD606
VPORT0603100KV05
R622 10K 1/10W 5%
12
ZD605
VPORT0603100KV05
R623 10K 1/10W 5%
12
ZD602
VPORT0603100KV05
R603 10K 1/10W 5%
2
1
4
3
A
B
CN601
JACK
2
1
4
3
A
B
CN602
JACK
2
1
4
3
A
B
CN603
JACK
R601 10K 1/10W 5%
12
ZD601
VPORT0603100KV05
C601 2.2uF/25V
R620 10K 1/10W 5%
R629
10K 1/10W 5%
R628
10K 1/10W 5%
YPbPr1_Audio_L
R619 10K 1/10W 5%
C602 2.2uF/25V
C603 2.2uF/25VC606 2.2uF/25V
R621 NC/10K 1/10W 5%
C608 2.2uF/25VC607 2.2uF/25V
AV1AudioInput
C622
560pF
C605
100pF
AUDIO_OUT_L
GND1 VCC2 VIN3
CN605
FIBER-OPTIC 3P
88T 78 13A37 YG
AUDIO_OUT_R
R630 100R 1/10W 5% Coaxial
C604
100pF
VCC5D
C620
0.1uF/16V
C609 2.2.uF/25VC610 2.2uF/25V
VGAAudioInput
YPbPr1AudioInput
88G 359 5 JT
YPbPr2AudioInput
88T 78 13A37 YG
88G 30252C
SPDIFOutput
88T 78 13A37 YG
R616 10K 1/10W 5%
C612 2.2uF/25VC611 2.2uF/25V
AV2_Audio_L4AV2_Audio_R4
R602 10K 1/10W 5%R604 10K 1/10W 5%
YPbPr1_Audio_R
R607
10K 1/10W 5%
AUDIO_OUT_L 13AUDIO_OUT_R 13
R606
10K 1/10W 5%
12
3
CN604PHONEJACK
R626 10K 1/10W 5%
12
ZD608
VPORT0603100KV05
R627 10K 1/10W 5%
12
ZD607
VPORT0603100KV05
C617
100pF
ADATAIN_0AC9
ADATAIN_1AD13
ADATAIN_2AF14
LINE_IN1_LM1
LINE_IN2_LL1
LINE_IN3_LK1
LINE_IN4_LJ1
LINE_IN5_LH1
LINE_IN6_LK3
LINE_IN1_RM2
LINE_IN2_RL2
LINE_IN3_RK2
LINE_IN4_RJ2
LINE_IN5_RH2
LINE_IN6_RJ3
Audio IN
U401E
ZR39775HGCF-BD
ACLK0 AD10
BCLK0AD9
ADATAOUT_0AC10
ADATAOUT_1 AD14
ADATAOUT_2AE14
LRCLK0AD12
LINE_OUT1_LAF12
LINE_OUT1_RAF11
LINE_OUT2_LAF10
LINE_OUT2_R AF9
IEC958_OUTAD11
VCM AE8
VREF_AADCAE12
VREF_ADACAE13
AGNDREFAF13
Audio OUT
U401I
ZR39775HGCF-BD
YPbPr2_Audio_RYPbPr2_Audio_L
1 2FB608 300 OHM
AMP_LIN 12,13AMP_RIN 12,13
C618
100pF
AV1_Audio_R
AV1_Audio_L
C623
10uF/16V
A_GND
C626
0.1uF/16V
C624
10uF/16V
C627
0.1uF/16V
C628
0.1uF/16V
C625
10uF/16V
A_GND
IEC958O
1 2FB614 30 OHM
YPbPr1_Audio_R
YPbPr1_Audio_L
C614
100pF
AMP_LIN
PC_Audio_LPC_Audio_R
AMP_RIN
C613
100pFR617
10K 1/10W 5%
54
12) Audio Amplifier
A24V
C632
NC
C649 0.22uF
GAIN0GAIN1
C635
1uF
C657
0.1uF 50V
AMP_SD
R647
NC
C643
NC/1uF
C653
NC/1uF
D602 LL4148
C645
0.001uF
R640
20K 1/10W 5%
1 2FB609NC/600 OHM
R661
2K OHM 1/4W
AUD_SHDN
PD_MUTE
PVCCL1
SD2
PVCCL3
LIN5
RIN6
MUTE4
BYPASS7
AGND8
AGND9
PVCCR10
VCLAMP11
PVCCR12
PGNDL24
PGNDL23
LOUT22
BSL21
AVCC20
AVCC19
GAIN018
BSR16GAIN117
ROUT15
PGNDR14
PGNDR13
TH
125
U602TPA3121D2PWPR
C641 0.22uFR656
2K OHM 1/4W
R646 10K 1/10W 5%
L603
22uH +-25%R660
10K 1/10W 5%
C637
0.1uF 50V
R670
NC
C644
0.22uF
R652
0 OHM 1/3W
C654
0.22uF
R642
10K 1/10W 5%
C636
0.1uF 50V
R641
NC
R655
560R 1/10W 5%
R658
560R 1/10W 5%
R635
51K 1/10W 5%
L602
22uH +-25%
U601AS431AN-E1C631
0.1uF 50V
1234
CN606
CONN
R634
10K 1/10W 5%
R649 0.5 OHM 2W
R645
1K 1/10W 5%
R638
NC
L601 NC/33 OHM
P24V
A24V
VCC5D
A24V
R637
NC
R639
680R 1/10W 5%
A24V
AMP_LIN11,13
+5VSB+ C629
470UF35V
AUD_SHDN8
A24V
C650
1uF
C642 33NF50VC646 33NF50V
C651 1uF
AMP_BYPASS
D3V3
+
C638
1000UF35V
C633
1uF
1 2D601
RB160M-60TE25
R644
100K 1/10W 5%
PD_MUTE
R636
100K 1/10W 5%
A24V
Q604MMBT3904
R648
100K 1/10W 5%
A_MUTE
R651
10K 1/10W 5%
AUD_AMP_MUTEAUD_AMP_MUTE8
AMP_SD
C630
1uF
R659
NC
C640
1uF
C648
1uF
AMP_RIN
A24V
R654
10K 1/10W 5%
R653
NC
AMP_LIN
PD_MUTE 13
+
C652
1000UF35V
+ C656
470UF35V
+ C634
470UF35V
1 2FB610NC/600 OHM
R657
0 OHM 1/3WAMP_RIN11,13
R662 NC
R666 NC
AMP_BYPASS
AMP_SD
Q605NC
R650
NC
Q602MMBT3904
C655
0.001uF
D3V3D3V3
R668 NC
C658 NC
R632
NC
P12V
R643 NC
C659
NC
R673
NC
U603NC/AS431AN-E1
R672
0R05 1/10W 5%
20
L+
1
0
26
L606 NC/33 OHM
R665
NC
1
P12V
R667 NC
A24V
D604
NC/LL4148
1
R-R+
36
For TPA3123
0
0
R
0
LL-
GAIN(dB)GAIN1
4P S/T 2.5mm
1
GAIN0
C660
NC
16.2mm
O=1.8mm3mm
R669
NC
6.2mm
25mm
R674
NC
HEAT SINKQ90G6119 5
A24V
32
33G3278 4D
Q603MMBT3904
D603 LL4148
R671
0R05 1/10W 5%
R663
NC/0R05 1/10W 5%
R664
NC/0R05 1/10W 5%GAIN0GAIN1
A24V
55
13) Earphone/AV Outputs
EarPhoneOutput
C621
2.2uF/25V
12V_AUD
AudioOutput
C686
2.2uF/25V
1 2FB615 30 OHM
88G 30211K
LINE_OUT_R
LINE_OUT_L
R6777K5 1/10W 5%
R67620K 1/10W 5% R679
7K5 1/10W 5%R680
20K 1/10W 5%
EarP_L
C669
NC/1000pF
PD_MUTE12
EAR_DET
C662
1uF/25V
C663
1uF/25V
EarP_R
AMP_RIN 11,12
1 2D606
RB160M-60TE25
1 2D605
RB160M-60TE25
C667
100pF
Q613MMBT3904
Q611MMBT3906
R6B8
1M 1/10W 5%
R6B3
680K 1/10W 5%
Q6092N7002K
Q6122N7002K
R6B2
100K 1/10W 5%
R6B6
100K 1/10W 5%
Q6102N7002K
R6A4 220R 1/10W 5%
R6B5 100K 1/10W 5%
C682
330pF
+
C680 10uF/25V
R688 NC/0R05 1/10W 5%
R685
47K 1/10W 5%
R6A6
NC
VCC5D
R6B1
100K 1/10W 5%
R675 NC
FB612 300 OHM
VO11
IN1-2
By pass3
GND4
Shutdown5IN2-6VO2 7VDD 8
U604
TPA6113A2DR
R686 100K 1/10W 5%
R6A5
NC
+ C671
100uF/25V
C668
100pF
C681
330pF
Q606MMBT3904
2
1
4
3
A
B
CN608
JACK88T 78 13A37 YG
Q6142N7002K
+ C685
100uF/25V
C670
1uF/25V
Q608MMBT3906
R687
1M 1/10W 5%
FB613 300 OHM
+
C679 10uF/25V
1OUT1
1IN-2
1IN+3
VCC-4
VCC+ 8
2OUT7
2IN- 6
2IN+5
U605
TL072CDR
1762345
CN607
PHONEJACK
R6B7
680K 1/10W 5%
C684
470pF
12
ZD611
VPORT0603100KV05
R6A3 220R 1/10W 5% L604 330 OHM
C683
470pF
R678
10K 1/10W 5%
R682
100K 1/10W 5%
R6A8
47K 1/10W 5%
R6A9
47K 1/10W 5%
R684
47K 1/10W 5%
12
ZD612
VPORT0603100KV05
L605 330 OHM
R6B4
47K 1/10W 5%
R6A7
47K 1/10W 5%
1 2FB611 120 OHM
D3V3
+5VSB
VCC5D
PD_MUTE
C619
0.1uF/16V
AUDIO_OUT_L11
EARPHONE_DET 8
AMP_LIN11,12
R698
100K 1/10W 5%
R694
100K 1/10W 5%C677
2.2uF/25V
+
C665 470uF/10V
+
C666 470uF/10V
AUDIO_OUT_L
EarP_L
EarP_R
R689
0R05 1/10W 5%
R699
47K 1/10W 5%
R692
51K 1/10W 5%
R633
NC
LINE_OUT_L
12V_AUD
R681
100K 1/10W 5%
5V_HP
R691
NC
5V_HP
Q601MMBT3904
R683 NC
PD_MUTE
C673
NC R695
51K 1/10W 5%
R6A1
47K 1/10W 5%
R6A2
100K 1/10W 5%
R697
100K 1/10W 5%
12V_AUD
12V_AUD
R690
0R05 1/10W 5%
C674
NCR693
100R 1/10W 5%
Q607 2SC2412KR
+ C675
100uF/25V
12
ZD610
VPORT0603100KV05
12
ZD609
VPORT0603100KV05
EAR_L
EAR_R
C678
2.2uF/25VC676
0.1uF/16V
R696
NC
LINE_OUT_R
AUDIO_OUT_R
P12V
C672
0.1uF/16V
AUDIO_OUT_R 11
+ C661
470uF/10V
C664
4.7uF 25V
AMP_LINAMP_RIN
56
14) Power
PWR_ON
1 2FB701 120 OHM
P12V10,12,13,15
+5VSB6,7,12,13
VCC5D4,5,6,7,11,12,13
3V3_STB5,6,7,8,10
5VT3
ADJ/GND1
OUTPUT2
INPUT3
U709AZ1117D-5.0-E1
D3V33,4,6,7,8,10,12,13
C708
0.01uF
D1V88,9,10
C742
0.1uF/16V
VCC1V18,10
P12V
+ C743
100uF 16V
+ C704
220uF/10V
C772
0.1uF 50V
C774
0.1uF 50VC771
1N50V
R749
0R05 1/10W
+ C702
220uF16V
+ C701
100uF 25V
C773
330P 50V
C768
10uF 16V
C744
22uF 10V
R748
47KOHM +-1% 1/10W
L705 4.7uH
C769
0.1uF 50V
FB704
NC / 33 OHMC767
0.1uF /50V
R742
15 OHM 1/10W
R740
10R 1/10W 5%
R750
15K 1/10W 1%
+5VSB
3V3_STB
C770
NC
VCC1
REF2
GND3
FB4 EN 5PGND6LX7VIN8
U706G5692P11U
C705
330P 50V
R741
10K 1/10W
Vout = 0.8x(R1+R2)/R2
R1
12
ZD703
NC/BZT52C6V2-7-FStandby
R2
L706 2.2uH
P24V12
5V
+ C749
220uF/25V
FromPowerBoard
+ C711
220uF/25V
12P S/T 2.5mm
E
R2C
Vout = 1.25x(R1+R2)/R1
R717
33K 1/10W 5%
C746
0.47uF/16V
24V
33G327812D
12V
B
R1
VOUT2
VIN3
GN
D1
U703G1084-33T43Uf
VCC5D
R703
NC/4K7 1/10W 5%
C750
0.1uF/16V
C728
0.1uF/16V
C729
0.001uF
+ C730
470uF 16V
Q701MMBT3904
R709
10K 1/10W 5%
R704
NC/4K7 1/10W 5%
123456789101112
CN701
CONN
R713
22K 1/10W 5%
+5VSB
R711
10K 1/10W 5%PWR_ON
Q702MMBT3904
R707
1K 1/10W 5%
PWR_ON8
+5VSB
+5VSB
R715
47K 1/10W 5%
8V3
C719
0.1uF 50V+ C721
220uF/35V
C720
0.001uF
P24V
VCC1
REF2
GND3
FB4
EN5PGND6LX 7VIN8
U707G5627F11U
+ C713
100uF 16V
C733
0.1uF/16V
C741
1UF/25V C734
NC/0.068uF/16V
C740
0.1uF/16V
R708
10R 1/10W 5%R705
10K 1/10WL701
4.7uH
C761
0.01uF
C738
0.1uF/16V
C731
1UF/25V
C739
22uF
C735
1000pF
Vout = 0.8x(R1+R2)/R2
R701 100R 1/10W 5%
R2
D1V8
Vout = 0.8x(R1+R2)/R2
R1
R714
39KOHM +-1% 1/10W
R712
18KOHM +-1% 1/10W
R737
24K OHM +-1% 1/10W
R736
1.8K OHM 1/10W 5%
R738
20K 1/10W 1%
C722
0.01uF
C726
0.1uF/16V
C727
1UF/25V
+ C736
220uF 10V
73G253S 46 B
73G253S 46 B
C718
1UF/25VR721
10R 1/10W 5%
+ C732
220uF 25V
C766
NC/0.068uF/16V
C765
1000pF
C759
4UF7 10V VCC1V1
VCC5D
C724
0.01uF
+ C763
220uF/25V
VCC5D
1 2
FB703
300 OHM
L704
4.7uH
+ C725
220uF 25V
R1
R702 100R 1/10W 5%
1 2
FB702
300 OHM
VCC1
REF2
GND3
FB4 EN 5PGND6LX7VIN8
U704G5627F11U
BL_BR_CTRL 10
C723
4UF7 10V
R2
C762
22uF
BL_ON_OFF 8
R735
10K 1/10W
C707
100pF
+ C745
100uF/25V
C747
0.1uF/16V
P12V
S1
S2
S3
G4
D8
D7
D6
D 5
Q703
AO4449 -7A/-30V
+5VSBC717
0.01uF
VCC5D
R733
2K2 1/10W 5%
3V3_STB
For Tuner
D3V3
R732
0R05 1/10W 5%R719 560R 1/10W 5%
VIN3
VOUT2
AD
J1
U708G9084T43U
R716
100R 1/10W 1%
1V8_STB
C706
0.1uF/16V
3V3_STB
C710
0.001uF
OUT2
IN3
GN
D1
U702AIC1084-18PE
C709
0.1uF/16V
L703
33 OHM
PS_ON
8V3 5VT
Q704MMBT3904
R718
10K 1/10W 5%
PS_ON
57
15) Power & GPIO Table
C760
NC/22uF
11
22
L702 NC/L
Light Sensor
R745 0R05 1/8W
C755
NC/0.1uF/16V
R746 0R05 1/8W OO
PANEL_5V
R728
NC/68K 1/10W 5%
USB_OC_N
Note
8051GPIO_P_16
O
AB13
C6
C10
GPIO_P_13
AD5
EARPHONE_DET
AB9
F5
BL_ON_OFF
R23 O
I
D4
VGA_VSYNC_DET
D12
D6
TEST_G12
PANEL_CTRL1
8051
D1V8_CHECK
U23
GPIO_P_7 O
MIPS
AB11
MIPS
8051
E4
VCLKx2 (TEST_G10)
I/OTYPE
8051
GPIO_P_2
GPIO_P_23
ADC8_INB
O
KEY_PWR
Function
IVGA Vsync Detect
GPIO_P_4
GPIO_P_25
Debug Mode
GPIO_P_6
AC14
ADC8_INE
LED Blue
R2
8051
I
System EEPROM Write Protect
PadNO.
PANEL LVDS Power ON/OFFD3V3_CHECK
Power ON
Vsync_in (TEST_G8)
8051
USB_EN_N
I/O
GPIO_P_26
GPIO_P_11GPIO_P_10
I
O
G3
D11
USB Power Enable
F4
E2VID1 (TEST_G1)
Function
8051
E5
AUD_SHDN
E3
AD6
GPIO_P_29
GPIO_P_0
AB20
TEST_G11
Vout = 1.0x(R1+R2)/R2
VGA_VSYNC_DET
VGA Hsync Detect
E1
GPO_5 (AFE_TEST1)
I
GPIO_P_14
I
8051
8051
GPIO_P_24
GPIO_P_15
D5
8051
Backlight ON/OFF
GPIO_P_17
TEST_MODE
I
GPIO_P_3
GPIO_P_9
GPO_4 (AFE_TEST2)
USB Power Over Current Flag Output
D9
ADC8_IND
H3
MIPS
O
73G253S 4 B
PadNO.
Reset DeModulator
ZR39775 GPIO #
R1
HDMISW_RESETN
AB16
VID0 (TEST_G0)
HDMI Switch Reset
TV Micro Bootstrap Config
GPIO_P_28
Amplifier Mute
VID3 (TEST_G3)
E6
AB19
Hsync_in (TEST_G9)
O
D10
AV2 S-Video Detect
GPIO_P_20
VID4 (TEST_G4)
SPI_WEN
ADC8_INA
O
VGA_HSYNC_DET
VCC1V1_CHECK
C7
VID5 (TEST_G5)
E11
AB18
8051
AB6
D8
C758 NC/220pF
F2
8051
8051
ADC8_INF
MIPS
TVM_BOOT
8051
PANEL_ON
VGA Hsync Detect
MIPS
8051
8051
AB17
O
Res_AA6
Keypad Power On
I
GPO_6 (AFE_TEST0)
O
DEMOD_RSTN
F1
AE5
I
D7
C11
Amplifier Shutdown
I
8051
O
GPIO_P_5
Function Key
VID6 (TEST_G6)
ADC8_ING
ZR39775 ADC #
LED RED
EEPROM_WP1
U24
GPIO_P_22
F3
VGA_HSYNC_DET
GPIO_P_8
LED_2AE6
GPIO_P_19
ZR39775HGCF GPIO Pin Table
AE9
VID7 (TEST_G7)
8051
GPIO_P_21
V6
GPIO_P_18
ADC8_INC
VGA Vsync Detect
8051
U6
8051
AD4
AC5
ZR39775HGCF ADC Pin Table
MIPS
For 32' 5V PANEL Power
AB8
C12
8051
PWR_ON
Signal
AB10
GPO_3 (AFE_TCLK_IN)GPO_2 (AFE_TCLK_OUT)
VID2 (TEST_G2)
Earphone Detect
AA6
IE12
GPIO_P_12
AV2_S_DET
GPIO_P_1
MIPS
AB14
O
LED_1
GPIO_P_27
Flash Write Protect
I
MIPS
G4
AUD_AMP_MUTE
8051
VGA_EDID_WP VGA EEPROM Write Protect
PANEL_5V_ON
Q705NC/MMBT3904
P12V
R722
NC/10K 1/10W 5%
Q706NC/MMBT3904
PANEL_ON
R723 NC/10K 1/10W 5%
+ C754
NC/100uF/16V
PANEL_ON8,10 R724 NC/22K 1/10W 5%
+ C751
NC/100uF/16V
R731
NC/12K 1/10W 5%
AFE_CLKAFE_XCLK AE3
K4
PANEL_CTRL2 PANEL Control 2
PANEL Control 1
P12V
C752
NC/0.1uF/16V
R729
NC/51K 1/10W 5%
PANEL_POWER
PANEL PWR CHECK
SW1
IN2
RSET3
GND4
SS/EN5 COMP6 FB7 BST8 99
U710NC/SC4525BSETRT
I AV1 S-Video DetectAV1_S_DETR726
NC/1K 1/10W 5%
C756
NC/220pF
C753
NC/0.22uF
R727
NC/2R2 1/10W 5%
R744 0R05 1/8W
R747 0R05 1/8W
D702 NC/LL4148
ZD704
NC/SM340A
R725NC/0R05 1/4W 5%
C757
NC/0.001uF
R730
NC/22K 1/10W 5%
PANEL_5V_ON
58
10.2 Power Board HL32D2 715G3332 1
R998
100K OHM 1/4W
ZD910NC
12
R919NC
+5V
-+
BD901D10XB60
2
1
3
4
C972
0.001uF
D951
1N4148
C9230.1uF
Q924DTC144WKA
R9881.8K OHM 1/4W
R91120K OHM 1/4W
R9578.2KOHM +-1% 1/8W
R932
1R 1/8W 5%
ON/OFF
C957
0.001uF
R997100K OHM 1/4W
R920680K OHM +-1% 1/4W
SG901NC
R965
1.8K OHM 1/4W
R981100 OHM 1/8W
R94251KOHM +-5% 1/4W
t
NR901NTCR
12
R9480.1 ohm
C944220pF
+C975470uF 35V
!
IC902
A6069H
1234 5
78S/OCP
BRGNDFB/OLP VCC
D/STD/ST
D940
SARS01-V1
R977100 OHM 1/4W
R993
100K OHM 1/4W
D950SBT15006JST
1
2
3
R9460.36 OHM +-5%
R936NC
R92313K OHM 1% 1/8W
R93910K OHM 1/4W
C9351000PF2KV
+C946470uF/25V
C912100pF
C9101uF/450V
ZD940NC1
2
B+
VCC
PDIM
C906470pF/250V
R968
6.8K OHM 1/4W
C919220pF,50V
R9696.8K OHM 1/4W
R980NC
+ C945470uF 35V
C9180.47uF/25V
D905
1N4148
R9853.6K OHM 1/8W
R973100 OHM 1/4W
C9560.1uF
R928100K OHM 1/8W
R903330K OHM 1/4W
IC952AZ431AZ-AE1
R951100 OHM 1/4W
R94322 OHM 1/8W
C92510nF
R97610K OHM 1/4W
R9051.5 MOHM +-5% 1/4W
ZD952
MTZJ T-72 15B
12
R9551K OHM 1/8W
C9390.01uF
Q921
KTD1691P
2
31
D970
SBR20010JST
1
2
3
C9070.1uF
R918
10K OHM 1/8W
C9420.1uF
C9550.22uF/50V
L906
310uH
1 2 5 678
R9753.9KOHM +-5% 1/8W
D910NC
R95047 OHM 1/4W
R994100K OHM 1/4W
R9741K OHM 1/4W
T902
POWER X'FMR
1
2
3
5
6
7891011
12
L950
L
F901
FUSE
C940NC
SG902NC
CN903
NC
12
LN
C916NCR917
56K OHM 1/8W
R931
2.2 OHM 1/4W
R972
1.8K OHM 1/4W
T901POWER X'FMR1
2
3
5
4
76
910
IC970EL817MC
12
43
C9340.1uF
+24V
R910300K OHM 1/4W
R92910K OHM 1/4W
C9221uF
FB902
BEAD
1 2
RV902NC
R992100K OHM 1/4W
R967
1.8K OHM 1/4W
!
C9080.1uF
R9041.5 MOHM +-5% 1/4W
R996100K OHM 1/4W
R9241M OHM 1% 1/4W
L901
13mH
1
2
4
3
IC903
LD7523PS
1234 5
678BNO
COMP(-)LATCHCS GND
OUTVCCOVP
D904
IN5408
R97824K OHM 1% 1/8W
R954100 OHM 1/4W
Q970PMBS3904
D942
NC
C9500.001uF
R9351K OHM 1/4W
C9010.47uF/275V
C9510.001uF
D932
JUMPER
R9251M OHM 1% 1/4W
PS_ON
R989
1K 1/8W 5%
R915470 OHM 1/8W
R96110K OHM
R9624.7M OHM 1/4W
C902680pF
+ C94110uF/50V
FB901
BEAD
1 2
CN902
CONN
123456789
101112
R959
100K OHM 1% 1/8W
VCC
R933
1R 1/8W 5%
D931
AU02Z
D903
1N4148
R927NC
+C93710uF/50V
R96310K OHM 1/8W
R9261M OHM 1% 1/4W
Q950PMBS3904
R906510KOHM +-5% 1/8W
D902FMN-1106S
R909
1.5 MOHM +-5% 1/4W
R9666.8K OHM 1/4W
+12V
+C91447uF/50V
R9384.7K OHM 1/8W
+ C920120uF M 450V
C9490.1uF
D9061N4148
C9780.1uF
R902330K OHM 1/4W
R9831K OHM 1/8W +-5%
RV901NC
R970100 OHM 1/4W
R9846.8K OHM 1/4W
L902
13mH
1
2
4
3
B+
C930NC
FB903
BEAD
1 2
C915470pF,50V
C9210.1uF
R916
0.12 OHM 2W
R9601K OHM
D972
SBR20010JST
1
2
3
C952
0.001uF
R986
1.8K OHM 1/4W
R971
1.8K OHM 1/4W
L951
L
R999100K OHM 1/4W
R9792KOHM +-1% 1/8W
�0.33uF
C903680pF
C9470.1uF
!
R991100K OHM 1/4W
C9480.1uF
!
R91310 OHM 1/8W
R964
2K OHM 1/8W
R94110K OHM 1/4W
C9240.001uF/250V
R921680K OHM +-1% 1/4W
+24V
+5V
B+_390V
A5V
D9011N4007-E3/73
+ C953330uF 16V
R908
2.2 OHM 1/4W
IC971AZ431AZ-AE1
FB
C9321000PF2KV
ZD930
MTZJ T-72 16B
12
+C933
10uF/50V
!
C9430.047uF
VCC
+12V
CN901
SOCKET
1 2
3
Q903STP10NK70ZFP
+C973470uF 35V
B+
+12V
Q901
STP20NM60FP
2
1
3
R94710K OHM 1/8W
R98727KOHM +-1% 1/4W
C970
0.001uF
A5V
IC951EL817MC
12
43
C904
0.47uF/275V
R901330K OHM 1/4W
D930
SARS01-V1
R956
1K OHM 1/8W
ZD970
MTZJ T-72 30B
12
IC950EL817MC
12
43
R94410K OHM 1/8W
C91110nF
PS_ON
R9588.2KOHM +-1% 1/8W
+C931100uF/50V
C9130.1uF
Q925KTA1273
2 1
3
L980
L
C9170.047uF
R91410K OHM 1/8W
R952
47 OHM 1/4W
R9374.7K OHM 1/8W
C905470pF/250V
B+_390V
FB!
D971
1N4148
IC901FAN7529MX
1 2 3 45678
INV
CO
MP
MO
TC
SZ
CD
GN
DO
UT
VC
C
+ C954470uF 16V
R922680K OHM +-1% 1/4W
+24V
C9090.01uF
R9451KOHM +-5% 1/4W
R9821K OHM 1/8W +-5%
R9072.2 OHM 1/4W
59
R804
10K OHM 1/8W
1
2
3
5
6
789
1011
12
T802P:S=42:42
C8221000pF
C82310nF
Q801AOTF12N50
B+_390V
TA
1
4
5
6
79
10
T80150:50:50 !
VSIS1
D807
1N4148
R801 0.1 ohm
!12
D802SCS0520P
12345
CN802
CONN
R8081M OHM 1/8W
PDIM
ON/OFF
+12V
C821
680PF/50V
L801
L
IS1
IS2
L1N2
CN801
CONN
DRV11
GND2
ZCS3
RT14
CT5
LCT6
PDIM7
VSEN8
ISEN9SSTCMP10TIMER11ADIM12ENA13VREF14VIN15DRV216
IC801
OZ9976GN
+C805470uF/25V C806
0.1uF/50V
R813NC
C8104N7 50V
TA
R8063.3MOHM1/8WR807
240K OHM 1/8W
R812150K OHM 1/8W
C8031000pF
C8081N 50V
R825
300 OHM 1/8W
IS2
D806
1N4148
R828
68K OHM 1/8W
R830
68K OHM 1/8W
R829
1M 1/8W
C8134N7 50V
R81551K
C8111U 25V
R81451K OHM 1/8W +-5%
ENA
R810100K OHM 1/8W
Q802AOTF12N50
12
D804SCS0520P
R831
1M 1/8W
C8120.022uF/25V
12D801
SCS0520P
12D803 SCS0520P
C8091U 25V
TB
C8142.2uF 25V X7R
TB
R8111.5M OHM 1/8W
C819NC(C1206)
C81747N 50V
IS2
C8022.2uF 25V X7R
C820
680PF/50V
C8011uF/450V
C8041uF/450V
R80562K OHM 1/8W
R826330 OHM 1/8W
R823
330 OHM 1/8W
IS1
R820100K OHM 1/8W
R83210K OHM 1/4W +-5%
R822
300 OHM 1/8W
R83310K OHM 1/4W +-5%
C807330PF/50V
R827
510 OHM 1/8W
Q804PMBS3904
VS
R809NC
VREF
Q803RK7002
VREF
R824
510 OHM 1/8W3
1
2
D805BAV70
C8161500pF
R8181.5K OHM 1/8W +-1%
R8219.1K OHM 1/8W
ISEN
ISEN
Q805PMBS3904
C81847N 50V
R81651 OHM 1/8W
C815220pF/25V
DR1
R8172.2K OHM 1/8W +-5%
R8191M OHM 1/8W
DR2
R802100 OHM 1/8W
R803100 OHM 1/8W
DR1 DR2
60
715G3645P01W30003S
R8806100 OHM +-5% 1/8W
R8814510 OHM +-5% 1/8W
6
21
4
T8802POWER X'FMR
VS
TA
IS1
D8821
1N4148
D88201N4148
C8818330pF 50V
IS2
1GPIN2
123
CN8803
CONN
P1 R8801100 OHM +-5% 1/8W
R8802100 OHM +-5% 1/8WP2
D88011N4148
TB
R88181K OHM 1/8W +-5%
6
21
4
T8806POWER X'FMR
C88135pF/6KV
R88231K OHM 1/8W +-5%
R8811510 OHM +-5% 1/8W
R8812510 OHM +-5% 1/8W
6
21
4
T8807POWER X'FMR
123456
CN8801
CONN
123
CN8802
CONN
TB
6
21
4
T8808POWER X'FMR
D88041N4148
VS
C88125pF/6KV
6
21
4
T8804POWER X'FMR
6
21
4
T8805POWER X'FMR
6
21
4T8803
POWER X'FMR
IS2
C88095pF/6KV
C88166N8 50V
C8819330pF 50V
C88246N8 50V
C88035pF/6KV
C88085pF/6KV
D88021N4148
C88055pF/6KV 3
12
D8819 D-BAV99-7-F
3
12
D8813D-BAV99-7-F
C88045pF/6KV
P21GPIN1
R880322KOHM +-1% 1/8W
R881622KOHM +-1% 1/8W
R88191K OHM 1/8W +-5%
R88201K OHM 1/8W +-5%
C88176N8 50V
C88256N8 50V
C88206N8 50V
C88216N8 50V
R88071K 1/8W
IS1
IS2
C8822220pF; 50V
1GPIN4
1GPIN31
GPIN6
1GPIN5
1GPIN8
1GPIN7
R88133K6 +-1% 1/8W
C88025pF/6KV
P3
R88173K6 +-1% 1/8W
P3
TA
P1
R880410KOHM +-5% 1/8W
R8805100K OHM 1/8W
C88011N 50V R8808
100KOHM +-5% 1/8W
D8806MTZJ T-72 5.1B
VS
3
12
D8809D-BAV99-7-F
3
12
D8815D-BAV99-7-F
6
21
4
T8801POWER X'FMR
3
12D8811
D-BAV99-7-F
3
12
D8817D-BAV99-7-F
61
HL42XD2 715G3351 1
F901FUSE
HS2HEAT SINK (Q901,D901)
12
- +
BD901D10XB60
2
1
3
4
R901300K OHM 1/4W
C9040.47uF
SG903NC
BO
CN902NC
1 2L N
RV901Varistor
SG901NC
C903680pF
HS3HEAT SINK (IC901)
12
CN901
12
3
L90320.0MH
1
4
2
3
FB901BEAD
12
HS6HEAT SINK (D904,D907)
12
HS5HEAT SINK (Q901)
12
L901
20.0MH
1
4
2
3
SG902NC
HS1HEAT SINK (BD901)
12
t
NR901
1 2
R903300K OHM 1/4W
HS4HEAT SINK (D910)
12
R+
C902680pF
R902300K OHM 1/4W
RV902NC
RV903NC
t
NR902
1 2
L9022.0MH
1 2
4 3
C9010.47uF
62
C819680pF
R847510K 1/10W 5%
R807240K 1/10W 5%
HS7HEAT SINK (Q806)
12
C810
VREF
R812180K 1/10W 5%
HS9HEAT SINK (Q807)
12
R83710K OHM 1/4W +-5%
R84882K 1/10W 5%
R83510K OHM 1/4W +-5%
Q813
RK7002FD5T116
090107
12V
D8091N4148
R852(NC)100K 1/10W 5%
+C80147uF/50V
IS2
VS
R825220 OHM +-1% 1/10W
R80562K OHM 1/8W
VSEN
C81733N 50V
C8091U 25V
12V
Q812RK7002FD5T116
VREF
C820680pF
C8120.047uF
R84010R 1/8W 5%
R815NC
T803
1
4
5
6
79
10
R816NC
T1
VREF
R801 0.1 ohm
D8101N4148
IS1
R822220 OHM +-1% 1/10W
B+
TB
IFP
R810100K OHM 1/4W
Q8012SK4086LS
+C805470uF 25V
R855(NC)1M 1/10W 5%
C8080.001uF
VS
TB
R8081M 1/8W 5%
-
+
U801A(NC)LM393MX
3
21
84
C8060.1uF
R820100K 1/10W 5%
R823NC
R84210R 1/8W 5%
CN802
CONN
12345
D8061N4148
HS10HEAT SINK (Q802)
12
DR1
R829
1M 1/10W 5%
D8071N4148
R813NC
VREF
C8142.2uF 25V X7R
C811
R849100K 1/10W 5%
R84110R 1/8W 5%
R8171K OHM
D8031N4148
R843200 OHM 1/8W
R83310K OHM 1/4W +-5%
ENA
D8011N4148-B4006
R853(NC)100K 1/10W 5%
IS1
R8191M +-5% 1/8W
R85110M OHM 1/10W
C81833N 50V
R8111.5M 1/8W 5%
R856 NC
R80936K OHM 1/8W
R824
HS8HEAT SINK (Q801)
12Q807
2SK4086LS
T801
1
4
5
6
79
10
DR2
T2
Q805PMBS3904
T2
Q810SST2907A
CN801
CONN
12L
N
R80410K OHM 1/4W +-5%
R826NC
Q814(NC)RK7002FD5T116
D802SCS0520P
12
T1
Q808SST2907A
R818
1K2 /8W 1%
R8031K2 1/8W 5%
R831
1M 1/10W 5%
R8021K2 1/4W 5%
L8013.5uH
IS1
D805BAV70
3
1
2
C8222.2uF 25V X7R
R8361K2 1/8W 5%
C8022.2uF 25V X7R
IS2
R844200 OHM 1/8W
R854(NC)100K 1/10W 5%
R845200 OHM 1/8W
Q8022SK4086LS
C823
NC
R8341K2 1/4W 5%
PDIM
Q804PMBS3904
DR2
R830
68K 1/10W 5%
IFP
TA
C8161500PF50V
C807330pF50V
IS2
Q8062SK4086LS
C803100PF1KV
R828
68K 1/10W 5%
IC801
OZ9976GN-C-0-TR
12345678 9
10111213141516
DRV1GNDZCSRT1CTLCTPDIMVSEN ISEN
SSTCMPTIMERADIMENA
VREFVIN
DRV2
R83910R 1/8W 5%
R81451K 1/8W 5%
C821100PF1KV
R850(NC)100K OHM 1/4W
D804SCS0520P
12
R83210K OHM 1/4W +-5%
DR1
ISEN
12V
T8021
2
3
5
6
789
1011
12
TA
C813
VSEN
Q811SST2907A
D808
1N4148-B4006
-
+
U801B(NC)LM393MX
5
67
84
R82110K 1/8W 5%
ISEN
C8152N2 50V
VSEN
090107
ON/OFF
Q815(NC)RK7002FD5T116
R846200 OHM 1/8W
R827
R857270KOHM +-5% 1/10W
Q803RK7002FD5T116
090107Q809SST2907A
R8063.3M OHM 1/8W
63
R914NC
CN903
123456789
101112
R941
+C91410uF/50V
+C912470uF 35V
R933
R9851.5 KOHM +-5% 1/4W L906
3.5uH
IC903KIA431A-AT/P
R9301M 1/4W 5%
C9240.01uF
FB902BEAD
1 2
R905100K OHM 1/4W
R9081.5 KOHM +-5% 1/4W
T902POWER X'FMR6
4
5
11
7
910
8
12
C9261uF
R906100K OHM 1/4W
R912NC
Q904KTA1273-Y- AT/ P
R9243.6K OHM 1/8W
R91822R 1/4W 5%
R91910K OHM 1/4W
IC902LD7523A
1234 5
678
BNOCOMP(-)LATCHCS GND
OUTVCCOVP
R922NC
C9220.047uF
24V
R911NC
IC909EL817MA
12
43
Q903DTC144WKA
B1+
C9102200PF2KV
R9361M 1/4W 5%
C9150.1uF
R923NC
R93810K 1/8W 5%
+C9201000uF 25V
R9071.5 KOHM +-5% 1/4W
C9130.1uF
R93710K 1/8W 5%
12V
R91722R 1/4W 5%
PS_ON
24V
R910100K OHM 1/4W
R92610K 1/8W 5%
C9081206 1NF K 500V X7R
R9311M 1/4W 5%
C9430.1NF2KV
R92551K 1/8W 5%
R92122 OHM 1/4W +-5%
D902SARS01-V1
C9180.1uF
R9351K 1/8W 5%
+C9191000uF 25V
C9170.0022uF
VCC1
C9250.33uF/50V
+C921470uF 25V
R909100K OHM 1/4W
B+
R915NC
R913NC
5V
R9044.7 OHM 1W
R934
C9071206 1NF K 500V X7R
PDIM
R9271K OHM 1/4W
D904FME-210B
1
2
3
Q901STP10NK70ZFP
ON/OFF
L905
3.5uH
R9323.9K OHM 1/8W
C923220pF
R9861.5 KOHM +-5% 1/4W
R929470 OHM 1/4W
R9402K OHM 1% 1/8W
R9164K7 1/4W 5%
D907FMX-12SL
1
2
3
+C9111000uF 35V
12V
D903JUMPER
C9160.0022uF
R9280.27OHM 2W
64
C9341uF/25V
R9581K 1/8W 5%
D9091N4148
R959470R 1/8W 5%
R95351K 1/8W 5%
R9430.1OHM2W
R94747 OHM 1/8W
Q902STW20NM60
2
1
3
Q906PMBS3904
D920SUF305B
R9450.1OHM2W
+C929
100uF M 450V
R94910K 1/8W 5%
PS_ON
C9361000pF
R955
R9513.3M OHM 1/14W
R956NC
IC904ICE2PCS02G
1 2 3 45678
GN
DIC
OM
PIS
ENS
EV
INS
VC
OM
PV
SEN
SE
VCC
GA
TE
R952220 OHM 1/4W
R+
Vcc
ZD902MTZJ T-72 16B
12
R95711.5K OHM 1% 1/8W
VCC1
R954180K 1/8W 5%
D9081N5408-E3/73
B+
C9271uF/520V
C938100pF
C937
R9602K7 1/8W 5%
C9330.1uF
C9351uF/25V
R9483.3M OHM 1/14W
D901FMXA-1106S
+C930
100uF M 450V
Q905KTD1691/P BY KEC
C9400.1uF
R96110K 1/8W 5%
5V
R944100R 1/8W 5%
R950
C9390.001uF/250V
R946
+C93110uF/50V
L904
P:S=50:28
1 2 3 56
7 8 9 10 11 12
C9320.1uF
C9280.1NF2KV
R9423.3M OHM 1/14W
IC905EL817MA
12
43
65
R9701M5 1/4W 1%
C9480.1uF
+C946
1000uF M 16V
D912SARS01-V1
C9440.0022uF
D9161N4148
R974NC
R963100K OHM 1/4W
C955
B1+
12V
C961(NC)0.1uF
24V
R9771M5 1/4W 1%
ZD905MTZJ T-72
12 ZD904
MTZJ T-72 15B
12
R9764.7M OHM 1/4W
R96933 OHM 1/4W
R966100K OHM 1/4W
ZD906NC
12
C9560.22uF/50V
ZD903MTZJ T-72 30B
12
C9420.1NF2KV
C962(NC)0.1uF
R97233 OHM 1/4W
R9788K2 1/8W 1%
C9490.0022uF
D9171N4148
R92010K 1/8W 5%
R9731M5 1/4W 1%
+C95247uF/50V
+C95410uF/50V
C906470pF/250V
C905NC
R9831K8 1/8W 5%
Vcc
Q907PMBS3904
T901POWER X'FMR1
2
3
5
4
76
910
D9151N4148
R97133 OHM 1/4W
R9673.3 OHM 1/4W
D9181N4148
5V
R980560K OHM 1% 1/8W
+C945
1000uF M 16V
D913PR1007
R975220 OHM 1/4W
C960
470pF/250V
D911JUMPER
+C958NC
C9590.1uF
BO
R9848K2 1/8W 1%
R96833 OHM 1/4W
C9570.22uF/25V
C9510.1uF
+C947
1000uF M 16V
IC907EL817MA
12
43
D910SBT15006JST
1
2
3
R98256R 1/8W 5%
D919PR1007
IC908KIA431A-AT/P
R9811.2OHM2W
C963(NC)0.1uF
ZD907NC
12
IC901A6069H
1 2 3 4578
S/O
CP
BR GN
DF
B/O
LPVC
C
D/S
TD
/ST
R965100K OHM 1/4W
+ C95347uF/50V
L907
3.5uH
R9791K 1/8W 5%
D914PR1007
R964100K OHM 1/4W
66
715G3358 2
R88230R05 1/8W
T8809POWER X'FMR
57
28
D88261N4148
D8819BAV99
3
12
D8812BAV99
3
12
R8802100R 1/8W 5%
R883024K 1/8W 5%
C88133pF 6KV
C88230.0056uF
C88083pF 6KV
P5
R881839K 1/8W 5%
T8805POWER X'FMR
57
28
C88123pF 6KV
R8813510R 1/8W 5%
D8815BAV99
3
12
D88021N4148
C88220.0056uF
C88320.0056uF
TB
C88330.0056uF
D8813BAV99
3
12
T8816
POWER X'FMR
57
28
D8823 BAV99
3
12
P5
C88053pF 6KV
R8812510R 1/8W 5%
D8811BAV99
3
12
R88220R05 1/8W
R8817510R 1/8W 5%
C88093pF 6KV
CN8801
CONN
123456
R8810100R 1/8W 5%
D88041N4148
C88163pF 6KV
TB
T8812
POWER X'FMR
57
28
P2
CN8803CONN
12
C88240.0056uF
T8802POWER X'FMR
57
28
R8815510R 1/8W 5%
R88290R05 1/8W
P7
R88280R05 1/8W
C88113pF 6KV
P6
R8801100R 1/8W 5%
CN8805CONN
12
IS2
R881939K 1/8W 5%
P7
CN8809CONN
12
R8809100R 1/8W 5%
R8821
10K 1/8W 5%
D8820 BAV99
3
12
D8824 BAV99
3
12
D88251N4148
T8801POWER X'FMR
57
28
TA
R8806100R 1/8W 5%
P3
T8806
POWER X'FMR
57
28
R8814510R 1/8W 5%
D8805MTZJ T-72 5.1B
C88103pF 6KV
CN8802
CONN
12L
N
C88280.0056uF
R88250R05 1/8W
C88250.0056uF
C88010.01uF
D88271N4148
C88143pF 6KV
C88173pF 6KV
D8816BAV99
3
12
R88240R05 1/8W
D88061N4148
C88290.0056uF
T8813POWER X'FMR
57
28
C88023pF 6KV
R8807
100K 1/8W 5%
T8808
POWER X'FMR
57
28
P4
D8822 BAV99
3
12
T8815POWER X'FMR
57
28
T8811POWER X'FMR
57
28
C88153pF 6KV
T8810
POWER X'FMR
57
28
C88200.0056uF
P2
IS1
C88063pF 6KV
VS
T8807POWER X'FMR
57
28
CN8808CONN
12
T8803POWER X'FMR
57
28
D8818BAV99
3
12
P6
R8816510R 1/8W 5%
TA
P1
IS2
D8817BAV99
3
12
R8811510R 1/8W 5%
IS1
D8821 BAV99
3
12
C88210.0056uF
P3
CN8810CONN
12
D8814BAV99
3
12
C88270.0056uF
R880410K 1/8W 5%
T8814
POWER X'FMR
57
28
D88071N4148
R882010K 1/8W 5%
D88081N4148
C88193pF 6KV
C8804
560PF/50V
R8808100R 1/8W 5%
C88073pF 6KV
C88310.0056uF
R8803100R 1/8W 5%
CN8804CONN
12
R88260R05 1/8W
T8804POWER X'FMR
57
28
C8834560pF50V
P1
C88183pF 6KV
D88031N4148
R8805100K 1/8W 5%
D88011N4148
CN8807CONN
12
C88300.0056uF
R88270R05 1/8W
CN8806CONN
12 P4
C8803
560PF/50V
VS
C88260.0056uF
67
10.3 Key Board 715G3293 1
R08 100R 1/10W 1%
VOL+
CH-
R06
NC/3.9K OHM 1/10W
PWR-SW
R03
1.8K OHM 1% 1/10W
GND PINGND PIN1
R02
2.7KOHM +-1% 1/10W
VOL-
~0.53V
FUNC_KEY
SW01
TACT SW FWRD H1.5MM
R05
750 OHM 1% 1/10W
Power ON/OFF
SW05
TACT SW FWRD H1.5MM
77G 607 2 FD
~1.72V
C01
NC/0.1uF/16V
Source Select
R04
1K OHM 1% 1/10W
CN01
CONN
1234
~2.59V
SW06
TACT SW FWRD H1.5MM
3V3_STB
PWR-SW
MENU
CH+
R01
7.5KOHM +-1% 1/10W
R07 750 OHM 1% 1/10W
C04
NC
~1.29V
SW07
TACT SW FWRD H1.5MM
SW04
TACT SW FWRD H1.5MM
C02
NC/4.7uF/16V
3V3_STB
SW02
TACT SW FWRD H1.5MM
C03
NC
SW03
TACT SW FWRD H1.5MM
~0.91V
FUNC_KEY
33G8032 4F HR
~2.12V
68
10.4 IR Board 715T3294 1
IRRV
056G 627503
C02
NC/4.7uF/16V33T8032 5F HR
081G 14 24 GP
C01
0.1uF/16V
BLUE
VOUT1
GND2
VCC3
U01
GP18B38BCE-HB
VCC
R01 15K OHM 1/10W
RED
12345
CN01
CONN
1
23
4
RED
BLUE
LED01LED
LED_BLED_R
69
11. Exploded View HL32D2
20
70
HL42XD2
71
HL32D2 No. Description Q'ty 1 BEZEL 1 2 SPEAKER 2 3 KEY COVER 1 4 KEY PAD 1 5 IR LENS 1 6 POWER LENS 1 7 POWER BOARD 1 8 32TV-BASE-SUPPORT-G3 1 9 32TV-VESA-BKT-G3 2 10 PANEL 1 11 NA 1 12 MAIN BOARD 1 13 IO SIDE COVER 1 14 REAR COVER 1 15 NA 1 16 HINGE 1 17 BASE 1 18 32TV BKT_BASE-1 1 19 RUBBER FOOT 6 20 REMOTE CONTROL FOR USA HAIER 1
Screw Lists
No. P/N Description Q'ty1 0D1G1730 8120 SCREW FOR MAIN,POWER AND INVERTER BOARD 14 2 0M1G 930 6 47 CR3 SCREW FOR IO COVER 2 3 0Q1G 930 8 47 CR3 SCREW FOR IO COVER 1 4 0M1G 940 6120 SCREW FOR TV-VESA-BKT 4 5 0M1G 940 6120 SCREW FOR BASE-SUPPORT 5 6 0M1G 940 12 47 CR3 SCREW FOR BASE 2 7 0Q1G 940 16 47 CR3 SCREW FOR BASE 2 8 0M1G1730 6120 SCREW FOR MAIN BOARD 2 9 0M1G1740 10120 SCREW FOR BASE-SUPPORT 2
10 0Q1G 940 14 47 CR3 SCREW FOR BEZEL/PANEL 2 11 Q01G6070 1 SCREW FOR BEZEL/PANEL 2 12 0Q1G 940 16 47 CR3 SCREW FOR REAR COVER 10
72
HL42XD2 No. Description Q'ty 1 IR BOARD 1 2 RUBBER FOOT 10 3 SHIELD COVER SIDE 1 4 BKT-VESA-BTM 2 5 STAND BRACKET 1 6 VESA BRACKET LCM 1 7 BASE BRACKET A1 1 8 INVERTER BOARD 1 9 POWER BOARD 1 10 MAIN BOARD 1 11 KEY BOARD 1 12 SPEAKER 2 13 PANEL 1 14 SHIELD COVER SIDE 1 15 KEY HOLDER 1 16 KEY PAD 1 17 IR LENS 1 18 POWER LENS 1 19 REAR COVER 1 20 NA 1 21 NECK COVER 1 22 STAND COVER A1 1 23 BEZEL 42 1 24 BASE COVER A1 1 25 IO SIDE COVER 1 26 HINGE ASS'Y 1 27 BOLT 2 28 POWER BOARD SUPPORT 1 29 CABLE TIE 1 30 TAPE_INSULATING 1 45 REMOTE CONTROL FOR USA HAIER 1
Screw Lists No. P/N Description Q'ty31 001G6021 1 SCREW FOR SPEAKER 4 32 0M1G 930 6 47 CR3 SCREW FOR HDMI 2 33 0Q1G 130 8 47 CR3 SCREW 6 34 0Q1G 940 14 47 CR3 SCREW 4 35 0Q1G 940 20 47 CR3 SCREW 8 36 0Q1G 940 30 47 CR3 SCREW 4 37 0M1G 940 5120 SCREW 5 38 0M1G1730 8120 SCREW 10 39 0M1G 940 12 47 CR3 SCREW 10 40 0M1G1830 8120 SCREW 5 41 0M1G1760 12225 CR3 SCREW 4 42 0Q1G1030 6120 SCREW 3 43 0Q1G 930 8 47 CR3 SCREW 4 44 0Q1G 940 10 47 CR3 SCREW 2