SERVICE MANUAL

HS-PX390HS-PX597

AH, D

AE, AK

STEREO CASSETTE PLAYER BASIC TAPE MECHANISM : 6ZM-2 P11NF

S/M Code No. 09-998-416-0R1

REVISION

MODEL CODE : 8ZHK5-0134<S>8ZHK5-0164<L>

2

Maximum output: 4 mW + 4 mW (EIAJ 32 ohms)<390AH>4 mW + 4 mW (EIAJ 16 ohms)<597>

Load impedance: 16�32 ohms<597 only>Power source: DC 1.2 V using supplied rechargeable battery NB-5G,

DC 1.5 V using an R6 (AA) dry cell battery,AC house current using optional AC adaptor

Maximum dimensions 80.1 (W) x 110.2 (H) x 24.1 (D) mm (31/4 x 43/8 x 31/32 in.)Weight Approx. 164 g, 5.7 oz (including the rechargeable battery, excluding the battery case)

Supplied headphones HP-M041<597 only>Type: In-ear typeImpedance: 32 ohmsSensitivity: 105 dB/mWRecommended commercially available headphonesType: In-ear type/Vertical type/Headband typeImpedance: 16�32 ohmsSensitivity: 100�109 dB/mW

<Battery charger RB-107>Rated voltage: AC 230V, 50 Hz<597>

AC 115 � 230 V, 50/60 Hz<390AH>

� Design and specifications are subject to change without notice.

SPECIFICATIONS<EXCEPT 390D> SPECIFICATIONS<390D>

3 4

DESCRIPTIONREF. NO. KANRINO.

PART NO. KANRINO.

REF. NO. DESCRIPTIONPART NO.

IC

87-A21-179-040 1H C-IC,TA2123AF87-A20-818-040 -- C-IC,NJM2185AV<597>87-A20-961-040 1E C-IC,MM1279XV87-A21-277-010 -- C-IC,ML63512-12287-A20-861-040 1A C-IC,S-80808ANNP

TRANSISTOR

89-111-624-080 0E TR,2SA1162Y87-026-417-080 0E TR,RN131087-026-480-080 0E TR,RN460589-333-266-080 0E CHIP TR,2SC3326B89-113-625-080 0E TR,2SA1362GR

89-341-165-080 0E CHIP TRANSISTOR 2SC4116GR87-026-423-080 -- C-TR RN2305<597>

DIODE

87-A40-666-040 -- C-DIODE,HN2S01F

MAIN C.B

C101 87-012-273-080 0E C-CAP,U 820P-50 BC102 87-012-273-080 0E C-CAP,U 820P-50 BC103 87-012-273-080 0E C-CAP,U 820P-50 BC104 87-012-273-080 0E C-CAP,U 820P-50 BC105 87-A10-031-080 0E C-CAP,U 0.01-25 KB<390>

C105 87-016-114-080 -- C-CAP,U0.01-25B<597>C106 87-A10-031-080 0E C-CAP,U 0.01-25 KB<390>C106 87-016-114-080 -- C-CAP,U0.01-25B<597>C107 87-A11-188-080 0E C-CAP,TN 22-4 AM004RC108 87-A11-188-080 0E C-CAP,TN 22-4 AM004R

C109 87-A11-188-080 0E C-CAP,TN 22-4 AM004RC110 87-A10-025-080 0E C-CAP,U 0.22-16Z FC111 87-012-278-080 0E C-CAP,U 2200P-50 BC112 87-A10-263-080 0E C-CAP,U 0.1-16ZFC113 87-A11-188-080 0E C-CAP,TN 22-4 AM004R

C115 87-A10-707-080 0E C-CAP,U 0.47U-16 F ZC116 87-A10-707-080 0E C-CAP,U 0.47U-16 F ZC117 87-A10-707-080 0E C-CAP,U 0.47U-16 F ZC118 87-016-562-080 0E C-CAP,TN 4.7-10C119 87-A11-797-080 -- C-CAP,S 2.2-16 Z F

C120 87-A10-263-080 0E C-CAP,U 0.1-16ZFC123 87-A10-263-080 0E C-CAP,U 0.1-16ZFC124 87-A10-263-080 0E C-CAP,U 0.1-16ZFC125 87-A10-706-080 0E C-CAP,U 0.33-16 ZFC126 87-A10-707-080 0E C-CAP,U 0.47U-16 F Z

C127 87-A11-056-080 0E C-CAP,U 1-10 Z FC128 87-A10-707-080 0E C-CAP,U 0.47U-16 F ZC129 87-016-562-080 0E C-CAP,TN 4.7-10 SV AC130 87-A10-260-080 0E C-CAP,U 0.1-16 K BC131 87-A11-797-080 -- C-CAP,S 2.2-16 Z F

C132 87-A11-797-080 -- C-CAP,S 2.2-16 Z FC133 87-016-317-080 0E C-CAP,TN 2.2-6.3C134 87-A11-056-080 0E C-CAP,U 1-10 Z FC135 87-A11-797-080 -- C-CAP,S 2.2-16 Z F<597>C136 87-A11-797-080 -- C-CAP,S 2.2-16 Z F<597>

C137 87-010-805-080 0E CAP, S 1-16C138 87-010-805-080 0E CAP, S 1-16C141 87-010-828-080 0E CHIP CAPACITOR,U 0.033-25FC142 87-010-828-080 0E CHIP CAPACITOR,U 0.033-25FC143 87-010-674-080 0E CAP, ELECT 220-2

C144 87-010-674-080 0E CAP, ELECT 220-2C148 87-A11-056-080 0E C-CAP,U 1-10 Z FC149 87-A10-707-080 0E C-CAP,U 0.47U-16 F ZC170 87-010-785-080 0E C-CAP,U 0.015-25 KB GRMC201 87-010-805-080 -- CAP, S 1-16<597>

C202 87-010-805-080 -- CAP, S 1-16<597>

C203 87-012-274-080 -- CHIP CAP,U 1000P-50B<597>C204 87-A11-187-080 -- C-CAP,TN 10-4 AM004R<597>C205 87-A11-188-080 -- C-CAP,TN 22-4 AM004R<597>C207 87-A10-369-080 -- C-CAP,S 0.47-16 K B<597>C208 87-A10-369-080 -- C-CAP,S 0.47-16 K B<597>

C209 87-016-460-080 -- C-CAP,S 0.22-16 B<597>C210 87-016-460-080 -- C-CAP,S 0.22-16 B<597>C301 87-A10-031-080 0E C-CAP,U 0.01-25 KBC302 87-A10-260-080 0E C-CAP,U 0.1-16 K BC303 87-A11-796-080 -- C-CAP,S 4.7-10 Z F

C304 87-A10-260-080 0E C-CAP,U 0.1-16 K BC305 87-A10-025-080 0E C-CAP,U 0.22-16Z FC306 87-A10-707-080 0E C-CAP,U 0.47U-16 F ZC307 87-A11-056-080 0E C-CAP,U 1-10 ZFC308 87-A10-031-080 0E C-CAP,U 0.01-25 KB

C309 87-A10-031-080 0E C-CAP,U 0.01-25 KBC601 87-A11-189-080 0E C-CAP,TN 47-4 BM004RC602 87-A11-188-080 0E C-CAP,TN 22-4 AM004RC701 87-010-505-080 0E CAP,CHIP TANTALUM 1-16C702 87-A10-263-080 0E C-CAP,U 0.1-16ZF

C703 87-A11-056-080 0E C-CAP,U 1-10 Z FC704 87-A10-263-080 0E C-CAP,U 0.1-16ZFC707 87-A11-056-080 0E C-CAP,U 1-10 Z FC708 87-A10-263-080 0E C-CAP,U 0.1-16ZF

C709 87-A10-263-080 0E C-CAP,U 0.1-16ZFC801 87-A11-812-080 -- C-CAP,E 220-4 MVS<597>C903 87-010-831-080 0E C-CAP,U 0.1-16 ZFC904 87-010-831-080 0E C-CAP,U 0.1-16 ZFC907 87-012-274-080 0E CHIP CAP,U 1000P-50B

C910 87-010-831-080 0E C-CAP,U 0.1-16 ZFC912 87-010-831-080 0E C-CAP,U 0.1-16 ZFC980 87-010-831-080 0E C-CAP,U 0.1-16 ZFC984 87-012-274-080 0E CHIP CAP,U 1000P-50BJ101 87-099-687-010 1A JACK,3.5BLK 4H

L901 87-A50-367-080 0E C-COIL, 10UH LQG21FLED501 87-A90-278-080 0E C-LED,SML-210VT REDPS401 87-A91-428-010 -- SNSR,PHOTO NJL5193K-F10R105 87-022-281-080 -- CHIP RES U 680-1/6W F<597>R106 87-022-281-080 -- CHIP RES U 680-1/6W F<597>

R107 87-022-281-080 -- CHIP RES U 680-1/6W F<597>R108 87-022-281-080 -- CHIP RES U 680-1/6W F<597>R203 87-022-252-080 -- C-RES,U36K-1/16WF<597>R709 87-022-286-080 0E C-RES U 100K-1/16WFR710 87-022-249-080 0E C-RES U27K 1/16WF

R983 87-012-274-080 0E CHIP CAP,U 1000P-50BS101 87-036-379-180 0E C-SW,SL1-1-2 SS350S102 87-A90-703-080 0E C-SW,SL 1-1-3 SSSS813-B-2BS201 87-036-379-180 -- C-SW,SL1-1-2 SS350<597>S701 87-A91-320-080 1A C-SW,SL 1-1-2 SSSS8A2-B-2B

S702 87-036-379-180 0E C-SW,SL1-1-2 SS350S703 87-A90-665-280 0E C-SW,TACT LS7A2MS704 87-A90-665-280 0E C-SW,TACT LS7A2MS705 87-A90-665-280 0E C-SW,TACT LS7A2MS706 87-A90-665-280 0E C-SW,TACT LS7A2M

S707 87-A91-421-010 -- SW,LEAF 6ZM-2(H)S708 87-A91-365-080 1A C-SW,PUSH 1-1-1 SPVG21S709 87-A91-461-010 -- SW,PUSH HXW4001SFR301 87-A91-465-040 -- C-SFR,K 6.8K H RH03AECTH301 87-A90-855-080 0E C-THMS,SC20-3K102K

VR101 87-A90-116-080 1B C-VR,RTRY20KCX2V0103X701 87-A70-151-110 1A VIB,XTAL 32.768KHZ VT-200

HEAD FLEX C.B

88-HK5-602-010 1H HEAD,ASSY 6ZM-2

5

8 8

A

Resistor Code

Chip Resistor Part Coding

Figure

Value of resistor

Chip resistor

Wattage Type Tolerance

1/16W

1/10W

1/8W

1608

2125

3216

5%

5%

5%

CJ

CJ

CJ

Form L W t

1.6 0.8 0.45

2 1.25 0.45

3.2 1.6

108

118

128

: A : A

CHIP RESISTOR PART CODE

0.55

Resistor CodeDimensions (mm)

Symbol

1/16W 1005 5% CJ 1.0 0.5 0.35 104L

t

W

6

ELECTRICAL MAIN PARTS LIST

IC BLOCK DIAGRAM- 1TRANSISTOR ILLUSTRATIONIC TA2123AF

2SA1363GR2SC4116GRRN1310

2SC3326BRN23052SA1162Y

BE

C

RN4605

B1

C1

E2

C2

E1

B2

7 8

14 13 12 11 10 9 8 7 6 5 4 3 2 1 1 2 3 4 5 6 7 8 9 10 11 12 13 14

A A

B B

C C

D D

E E

F F

G G

H H

I I

J J

K K

L L

M M

N N

O O

P P

Q Q

R R

S S

T T

U U

WIRING (MAIN)

109

P H

SCHEMATIC DIAGRAM (MAIN)

1211

14

1 AF IN I H: exist music, L: no music.

2 SCLK I Input serial clock ( Not used) .

3 MUTE O H: mute OFF, L: mute ON.

4 SDATA O Output serial data (Not used).

5 F/R CONT O H: REV mode, L: FWD mode.

6 MS-SENS O H: FF/REW (include MS, BS), L: Other.

7 MOTDIR O H: counterclockwise, L: clockwise.

8 P-SNSRIN I Input photo sensor.

9 AF MOMITOR O H: when AF IN "L" level, L: when AF IN "H" level (Not used).

10 MOT ON O H: motor ON, L: motor OFF.

11 MOT BR O H: motor brake ON, L: motor brake OFF.

12 HOLD IN I H : hold OFF, L : hold ON.

13 NC - Not connected.

14 NC - Not connected.

15 KEY MAIN I Main unit key input.

16 REMOTE I Remote controller key input.

17 P- SNSR K O Output for P-SNSR control.

18 LOAD CTL O Output for battery capacity checking.

19 LED K O Output for OPE, BATT LED control.

20 MOTOR ON L O H: when motor on "L" level, L: when motor on "H" level.

21 VDDI - Interface power supply for external equipment.

22 VSS - Power supply ( - ).

23 VDD - Power supply ( + ).

24 VDDH - Power supply booster for backup.

25 CB1 - Connected to capocitor for power supply booster.

26 CB2 - Connected to capocitor for power supply booster.

27 VDDL - Power supply ( + ) for internal logic.

28 XT0 - Connected to crystal oscillator for low speed.

29 XT1 - (32.768 kHz).

30 VDD - Test terminal.

31 VDD - Test terminal.

32 OSCM - Connected to capacitor for hi speed clock(Not used).

33 OSC0 - Connected to crystal oscillator for hi speed(Not used).

34 OSC1 - (Not used).

35 RESET I Input reset.

36 BEEP O Output beep sound.

37 CASS SW I H: not exist cassette, L: exist cassette.

38 MOTOR CH I Detect motor rotation.

39 LOAD CTL2 O Output for battery capacity checking.

40 TIMING SW I Input mechanism operation detection.

41 REMOTE DET I Switching level detector.

Pin No. Pin Name I/O Description

IC, ML63512-122

IC DESCRIPTIONIC NJM2185AV

IC BLOCK DIAGRAM- 2

IC MM1279XV

13

42 SET STOP I H: normal operation, L: stop mechanism.

43 P-CHECK O Output for photo sensor puls checking(Not used).

44 FF/REW O H: when MS-SENS. �L� level, L: when MS-SENS. �H� level.

45 POWER ON O H: power ON, L: power OFF.

46 P-SNSR DET I H: ignore input when existing play sound, L: always monitor photo sensor.

47 EJECT SW I Input for eject operation detection. H: normal, L: when EJECT is ON.

48 BS/MODE IN I H: continuns playback. enable BS, L: go&return playback. disable BS.

15

Pin No. Pin Name I/O Description

IC, ML63512-122

IC DESCRIPTION

16

17

18

ADJUSTMENT

SFR 301

MAIN C.BA

PHONES

J101

1

1

VR101

VOLUME

TP1(R-CH)

(L-CH)TP2

IC701

1

2

GND

IC301

2

2 2

3

4

2

<TAPE SECTION>Tape speed : 3015Hz ± 50HzWow : Less than 0.52% (RMS)Take-up torque : 20 ~ 30g-cm (FWD, RVS)F.F torque : 70 ~ 150g-cmREW torque : 70 ~ 150g-cmS/N ratio : More than 42dB (PB, DC)Distortion : Less than 3.0% (PB, DC)Noise level : Less than 3.0mV

(Vol MAX, PB, DC)Less than 0.4mV(Vol MIN, PB, DC)

Frequency response : 63Hz + 3 / � 5dB ~ 8kHz + 4 / � 4dB(NORMAL)63Hz + 3 / � 5dB ~10kHz + 4 / � 4dB(CrO2)

Test tape : TTA� 100TTA� 200TTA� 210TTA�310(CrO2)TTA�320(NORMAL)

19

<TAPE PLAYER SECTION>1. Tape Speed Adjustment

Settings : � Test tape : TTA�100 (Tape center)� Test point : PHONES (J101)� DSL : OFF� Adjustment location : SFR301� DOLBY SW : OFF<597 only>� TAPE SELECTOR : NORM(auto)� VOLUME : MAX

Method : Play back (FWD) the test tape and adjustSFR301 so that the frequency becomes3015Hz±10Hz. Then confirm WOW is lessthan 0.50%.

2. Dolby level check<597 only>

Settings : � Test tape : TTA�200� Check point : TP1(RCH), TP2(LCH)� DOLBY SW : OFF� DSL : OFF� TAPE SELECTOR : NORM� VOLUME : MINI� Adjustment points : Soldering patterns -

Precedure : Short the patterns via solder as showen in the tableso ghe Dollby NR level is 32mV ± 1.0dB. Adjustso the specifications are satisfied in both theforwardans reverse directions. Connect 10uF/16V couplingcapacetors between test points and test wquipment(connect the positive terminals to the test points).

SODER POINT INCRESE LEVEL

only 0.8 dB

LCH only 1.5 dB

& 2.3 dB

only 0.8 dB

RCH only 1.5 dB

& 2.3 dB

41

PRACTICAL SERVICE FIGURE

2

3

1

4

1

2

3

4

MECHANICAL EXPLODED VIEW 1/1<390>

20

HS-PX390(FileName:EXPLODED.EPS)99/7/22

1

D

1

D

2

3

4

5

633

K

M

K

SPACER,PWB K

32

JACK

98

7

1011

EF

BA

AB

J

J

L

12

19

14

15

13

6ZM-2 P11NF31

30PCB

18

128

27

26

25

24

22

29

23

H

G

G

H16

17

O

21

D

N

D

20

DESCRIPTIONREF. NO. KANRINO.

PART NO. KANRINO.

REF. NO. DESCRIPTIONPART NO.

MECHANICAL PARTS LIST 1/1<390>

1 8Z-HK5-026-010 1H LID ASSY,CASS BLU<390L>1 8Z-HK5-018-010 1H LID ASSY,CASS D<390S>2 8Z-HK5-216-010 0E SPR-P,POP-UP3 8Z-HK5-214-010 1C HLDR ASSY,CASS MOT4 88-HK5-208-010 0E ARM,SLIDE

5 8Z-HK5-213-010 1A HLDR,CASS JACK6 8Z-HK5-005-010 0E WINDOW,CASS7 8Z-HK5-038-010 0E KNOB,SL BS SIL<390L>8 8Z-HK5-012-010 0E KNOB,SL BS9 8Z-HRB-207-010 0E SPR-P,CASS

10 8Z-HK5-016-010 1B FRAME,CENTER D<390S>10 8Z-HK5-032-010 1B FRAME,CENTER SIL<390L>11 8Z-HK5-202-010 0E PLATE,HINGE MOT12 88-HK5-220-010 0E SPR-P,MECHA EARTH13 8Z-HK5-006-010 0E LID,BATT<390S>

13 8Z-HK5-033-010 0E LID,BATT BLU<390L>14 8Z-HK5-206-010 0E BAT-CONTACT,P15 88-HK5-216-010 0E SHAFT,BAT16 8Z-HK5-209-010 0E HLDR,CONT B-BOX17 8Z-HK5-207-010 0E BAT-CONTACT,BOX HEAD

18 8Z-HK5-224-010 0E SPR-E,OPEN19 8Z-HK5-226-010 1A BAT-CONTACT,M20 8Z-HK5-204-010 1A PLATE,B-BOX21 8Z-HK5-029-010 1H CABI,REAR BLU<390L>21 8Z-HK5-019-010 1H CABI,REAR D<390S>

22 8Z-HK5-009-010 1B KNOB,RTRY HOLD23 8Z-HK5-008-010 0E LENS,LED24 8Z-HK5-010-010 0E KNOB,SL OPEN25 8Z-HK5-013-010 0E KNOB,SL DSL26 8Z-HK5-210-010 0E HLDR,KNOB OPEN

27 8Z-HK5-221-010 0E SPR-T,CLICK28 8Z-HK5-222-010 0E JOINT,HOLD29 8Z-HK5-004-010 1A PANEL,CABI30 8Z-HK5-007-010 1B KEY,CONT31 8Z-HK5-203-010 1A PLATE,OPEN

32 8Z-HK5-011-010 0E KNOB,SL TP33 8Z-HK5-201-010 1A PLATE,HINGE JACKA 87-HK5-238-010 0E S-SCRWE,1.4-1 BLK NL<390S>B 87-HK5-240-010 0E S-SCREW,1.4-1 CR NL<390L>C 87-067-588-010 0E SCREW,V+1.4-1.4

D 87-HK5-237-010 0E S-SCREW,1.4-2 CR NL E 87-078-116-010 0E SCRW M1.4-2.5B NL<390S> F 87-078-117-010 0E SCRW M1.4-2.5CR NL<390L> G 87-067-746-010 0E SCREW,M 1.4-2(H0.5) H 87-078-052-010 0E S-SCREW+1.4-3.5HL(B)

I 8Z-HK5-227-010 0E S-SCREW,+1.7-3.5 BLK HL J 87-HK5-235-010 0E S-SCREW,1.4-0.6-2.5 K 87-067-385-010 0E SCREW,VT +1.4-2.5HL L 88-HK5-228-010 0E S-SCREW,+1.4-2 CR M 86-HK4-223-010 0E S-SCREW,SERR+1.4-3.5 B L

N 87-067-597-010 0E VT1.4-25HL O 8Z-HK5-229-010 0E S-SCREW,+1.4-2.5 CR NL

Basic color Color Basic color Color Basic color Color symbol symbol symbol

B Black C Cream D Orange

G Green H Gray L Blue

LT Transparent Blue N Gold P PinkR Red S Silver ST Titan Silver

T Brown V Violet W White

WT Transparent White Y Yellow YT Transparent Yellow

LM Metallic Blue LL Light Blue GT Transparent GreenLD Dark Blue DT Transparent Orange

COLOR NAME TABLE

21

MECHANICAL EXPLODED VIEW 1/1<597>

HS-PX597(FileName:EXPLODED.EPS)99/7/22

1

D

1

D

2

3

4

5

68

K

M

K

SPACER,PWB K

32

JACK

97

1011

EF

AA

J

J

L

12

19

14

15

13

6ZM-2 P11NF31

30PCB

18

128

27

26

25

24

22

29

23

H

G

G

H16

17

F

21

D

B

D

20

22

DESCRIPTIONREF. NO. KANRINO.

PART NO. KANRINO.

REF. NO. DESCRIPTIONPART NO.

MECHANICAL PARTS LIST 1/1<597>

87-HK5-236-010 S-SCREW,1.4-2.3 1 8Z-HK5-015-010 LID ASSY,CASS<597AK,597AE> 1 8Z-HK5-018-010 LID ASSY,CASS D<597AH> 2 8Z-HK5-216-010 SPR-P,POP-UP 3 8Z-HK5-214-010 HLDR ASSY,CASS MOT

4 88-HK5-208-010 ARM,SLIDE 5 8Z-HK5-213-010 HLDR,CASS JACK 6 8Z-HK5-005-010 WINDOW,CASS 7 8Z-HK5-012-010 KNOB,SL BS 8 8Z-HK5-201-010 PLATE,HINGE JACK

9 8Z-HRB-207-010 SPR-P,CASS 10 8Z-HK5-003-010 FRAME,CENTER<597AK,597AE> 10 8Z-HK5-016-010 FRAME,CENTER D<597AH> 11 8Z-HK5-202-010 PLATE,HINGE MOT 12 88-HK5-220-010 SPR-P,MECHA EARTH

13 8Z-HK5-006-010 LID,BATT 14 8Z-HK5-206-010 BAT-CONTACT,P 15 88-HK5-216-010 SHAFT,BAT 16 8Z-HK5-209-010 HLDR,CONT B-BOX 17 8Z-HK5-207-010 BAT-CONTACT,BOX HEAD

18 8Z-HK5-224-010 SPR-E,OPEN 19 8Z-HK5-226-010 BAT-CONTACT,M 20 8Z-HK5-204-010 PLATE,B-BOX 21 8Z-HK5-002-010 CABI,REAR 22 8Z-HK5-009-010 KNOB,RTRY HOLD

23 8Z-HK5-008-010 LENS,LED 24 8Z-HK5-010-010 KNOB,SL OPEN 25 8Z-HK5-013-010 KNOB,SL DSL 26 8Z-HK5-210-010 HLDR,KNOB OPEN 27 8Z-HK5-221-010 SPR-T,CLICK

28 8Z-HK5-222-010 JOINT,HOLD 29 8Z-HK5-004-010 PANEL,CABI 30 8Z-HK5-007-010 KEY,CONT 31 8Z-HK5-203-010 PLATE,OPEN 32 8Z-HK5-011-010 KNOB,SL TP

A 87-HK5-238-010 S-SCRWE,1.4-1 BLK NL B 87-067-597-010 VT1.4-25HL C 87-067-588-010 SCREW,V+1.4-1.4 D 87-HK5-237-010 S-SCREW,1.4-2 CR NL E 87-078-116-010 SCRW M1.4-2.5B NL

F 8Z-HK5-229-010 S-SCREW,+1.4-2.5 CR NL G 87-067-746-010 SCREW,M 1.4-2(H0.5) H 87-078-052-010 S-SCREW+1.4-3.5HL(B) I 8Z-HK5-227-010 S-SCREW,+1.7-3.5 BLK HL J 87-HK5-235-010 S-SCREW,1.4-0.6-2.5

K 87-067-385-010 SCREW,VT +1.4-2.5HL L 88-HK5-228-010 S-SCREW,+1.4-2 CR M 86-HK4-223-010 S-SCREW,SERR+1.4-3.5 B L

Basic color Color Basic color Color Basic color Color

symbol symbol symbol

B Black C Cream D OrangeG Green H Gray L Blue

LT Transparent Blue N Gold P Pink

R Red S Silver ST Titan Silver

T Brown V Violet W WhiteWT Transparent White Y Yellow YT Transparent Yellow

LM Metallic Blue LL Light Blue GT Transparent Green

LD Dark Blue DT Transparent Orange

COLOR NAME TABLE

23

TAPE MECHANISM EXPLIDED VIEW 1/1

24

2

3

4

5

6

6

1

7

8

9

1011

43

41

42

20

21

22

25

26

22

23

44

18

39

38

ab

c

d

e

a

b

c

d

e

f

HEAD FLEX C.B

43

32

40

SH,1.2-2.9-0.25SL

SH,1.2-2.9-0.25SL

13

15

24

27

28

30

31

34

35

36

37

17

17

29

16

F

49

49

19

45

46

47

33

12

f

D

A

50

50

C

B

B

20

C

Gg

g

51

14

53

48

HLDR,FP

PLATE,THRUST

52

E

H

54

54

DESCRIPTIONREF. NO. KANRINO.

PART NO. KANRINO.

REF. NO. DESCRIPTIONPART NO.

1 87-B30-038-010 -- BAT,NB-5G2 8Z-HK5-952-010 -- BOX,BAT ASSY BLU<L>2 88-HK5-952-110 1H BOX,BAT ASSY SIL<EXCEPT L>3 82-HK3-951-010 1C CARRYING,CASE<AK,AE>4 87-B30-039-010 2A CHARGER,RB-107 D<D,L>

4 87-B30-083-010 2M CHARGER,RB-107 E<AE>4 87-B30-137-110 2A CHARGER,RB-107 H<AH>4 87-B30-097-010 2A CHARGER,RB-107 K<AK>5 87-B30-253-010 2M HEADPHONE,HP-M0416 8Z-HK5-901-010 -- IB,D<D,L>

6 8Z-HK5-908-010 -- IB,E(EDPHNCZ)<AE>6 8Z-HK5-907-010 -- IB,E(EGFSI) S<AK,AE>6 8Z-HK5-905-010 -- IB,H(ECK)S<AH>7 8Z-HK5-951-010 -- RC UNIT,RC390

TAPE MECHANISM PARTS LIST 1/1

25

ACCESSORIES / PACKAGE LISTDESCRIPTIONREF. NO. KANRI

NO.PART NO.

!

!!!

1 86-ZM2-255-010 0E SPR-T,PIN BACK L2 86-ZM2-252-610 0E GUIDE,TAPE3 86-ZM2-220-210 0E SPR-T,HEAD4 86-ZM2-219-510 0E LEVER,HEAD5 86-ZM2-347-010 0E LEVER,MS EJECT

6 86-ZM2-368-110 0E ROLLER ASSY,PINCH L P117 86-ZM2-254-010 0E SPR-T,PIN BACK R8 86-ZM2-370-110 0E SPR-T,PINCH L P119 86-ZM2-229-110 0E SPR-T,PINCH R

10 86-ZM2-240-110 0E CAP,REEL

11 86-ZM2-234-110 0E SHAFT,REEL R12 86-ZM2-251-310 0E SHAFT,GEAR B13 86-ZM2-201-E10 1B CHAS ASSY,OUT-SERT14 86-ZM2-349-010 0E SPR-E,EJECT15 86-ZM2-232-310 0E LEVER,REEL R

16 86-ZM2-268-310 0E SHAFT,PULLEY BELT 217 86-ZM2-243-310 0E SPR-C,BT18 86-ZM2-329-210 0E BELT,P519 86-ZM2-209-310 0E GEAR,B20 86-ZM2-238-710 0E GEAR,FF

21 86-ZM2-245-410 0E SPR-C,SLIP L22 86-ZM2-237-010 0E GEAR,PLAY23 86-ZM2-241-310 0E SPR-C,SLIP R24 86-ZM2-272-010 0E LEVER,SW P 8.425 86-ZM2-236-510 0E CAP,SLIP

26 86-ZM2-235-210 0E SHAFT,REEL L27 86-ZM2-223-310 0E LEVER,PIN UP L28 86-ZM2-233-310 0E LEVER,REEL L29 86-ZM2-208-310 0E GEAR,A30 86-ZM2-217-210 0E SPR-E,CAM L

31 86-ZM2-216-510 0E LEVER,CAM L32 86-ZM2-276-010 0E PULLEY,COUPLER33 86-ZM2-212-310 0E SHAFT,FR34 86-ZM2-214-510 0E LEVER,CAM R35 86-ZM2-215-210 0E SPR-E,CAM R

36 86-ZM2-222-410 0E LEVER,PIN UP R37 86-ZM2-218-310 0E LEVER,HEAD UP38 86-ZM2-205-410 1A FLY-WHL,L39 86-ZM2-330-010 1A FLY-WHL,R240 86-ZM2-284-010 0E SH,AUTO 3

41 86-ZM2-225-310 0E ARM,PINCH L42 86-ZM2-224-210 0E ARM,PINCH R43 86-ZM2-283-210 0E CAP,SHAFT44 86-ZM2-275-310 0E CAP,SLIP R45 86-ZM2-210-710 0E LEVER,FR

46 86-ZM2-211-210 0E GEAR,FR47 86-ZM2-213-210 0E SPR-C,FR48 M8-7ZS-690-000 -- ABL-76 A49 86-ZM2-221-010 0E CLR,BRG N50 86-ZM2-239-010 0E FELT,

51 86-ZM2-342-010 1B LEVER ASSY,EJECT52 86-ZS2-312-010 0E SPR-P,6A-MOT53 87-ZS6-301-010 1D COIL,FP 7ZS654 86-ZM2-206-310 1A SHAFT,CAPSTAN

A 86-ZM2-278-010 0E W-P,1.36-4-0.2 SLT

B 86-ZM2-319-010 0E W-L,0.95-3-0.35C 87-067-860-010 0E PW,3-0.95-0.4D 87-067-516-010 0E PW,3-1.58-0.25,SLITE 87-067-430-010 0E VT1.4-5 BLKF 86-ZM2-348-010 0E S-SCREW,+1.4-4.6

G 87-261-500-310 0E SCREW V+1.4-1.4 (BK)H 87-067-815-110 0E VT+1.4-3(HL)

2�11, IKENOHATA 1�CHOME, TAITO-KU, TOKYO 110, JAPAN TEL:03 (3827) 3111

L

Printed in Singapore

A 4

2-11, IKENOHATA 1-CHOME, TAITO-KU, TOKYO 110, JAPAN TEL:03 (3827) 3111

931261 9820572