SAMPLE RESIDENCE - Avila Solar · 2019. 10. 24. · 8. 3111.5.3.1 - total system weight shall not exceed 4.5 psf. pv modules and racking shall be directly attached to roof framing

53.00'

128.7

5'

128.7

5'

53.75'

PV-1

PV SITE PLAN

OWNER

BUILDING

DATA

APPLICABLE

CODES

SYSTEM

MODULE

SPECS

CONTRACTOR

ROOF SPECS

PROJECT INFORMATION

PROJECT NOTES

NUMBER OF ARRAYS PROPOSED: 3

ARRAY # 3 DETAILS # OF MODULES: 5 TILT: 30° AZIMUTH: 180°



CONTRACTOR

Contractor# XXXXXDrawn by: Date:

Page:

Rev:

Ph:Ph:

System AC Size @ STC: System DC Size @ STC:YOUR LOGO

SAMPLE RESIDENCEResidential Grid Interactive Solar Installation1234 ANY STREET, ANY CITY, OR, 97007

(971)-240-7102

DA Sample Set 4/4/2018

4.56 kW 4.67 kW

(8) SOLARWORLD SW 295 MONO & (11) KYOCERA KD210GX-LPU SOLAR MODULES

(19) IQ6-60-2-US MICRO INVERTERS

123 ANY STREETANY CITY, WA 98660

(971)-240-7102

ANY INSTALLER

(E) RESIDENCE

S

W

N

E

(E) METER , (E) PANEL,(N) AC PV DISCONNECT,(N) AC IQ ENVOY

(N) ARRAY #1 (N) ARRAY #3

(N) ARRAY #2

NE HALSEY ST

SITE PLAN NOTE: CHECK WITH CITY/COUNTY OR LANDSURVEYOR FOR ACCURATE PROPERTY LOCATE.

SITE DETAILS

DRAWING LIST

PV-3: ELECTRICAL PLAN

PV-2: FRAMING PLAN

PV1: TITLE SHEET

PV-4: THREE LINE DIAGRAM

PV-5: LABELS

APPENDIX: DATA SHEETS

SAMPLE RESIDENCE1234 ANY STREET, ANY CITY, OR, 97007(971)-240-7102

SINGLE FAMILYRESIDENTIAL

2014 OREGON STRUCTURAL CODE (SECTION 3111)

(8) 295W SOLARWORLD SW 295 MONO = 2.36 KWdc @ STC(11) 210W KYOCERA KD210GX-LPU = 2.31 KWdc @ STCTOTAL: 4.67 KWdc @ STC


SOLARWORLD SW 295 MONO: (L) 65.94" X (W) 39.37" X (H) 1.30",WEIGHT = 39.7 LBSKYOCERA KD210GX-LPU: (L) 59.06" X (W) 39.37" X (H) 1.40",WEIGHT = 40.8 LBSCOMBINED WEIGHT OFMODULES AND RACKING ≤ 4.5 PSF

ANY INSTALLER123 ANY STREETANY CITY, WA 98660CONTACT: YOUR NAMEPHONE: (971)-240-7102

COMPOSITE SHINGLE ROOFING 2X4 RAFTERS@ 24" O.C., DOUGLAS FIR #2 (TRUE DIMENSION)TILT: 30°AZIMUTH: 270°, AND 180° (S)AREA OF ROOF(PLAN VIEW)= 1,946 SFAREA OF NEW ARRAY(S) = 279 SF (ARRAY< 14%OF ROOF AREA)

CLIMATE DATA SOURCE: PORTLANDINTERNATIONAL AP, OR, USA, 45.59N, 122.60WASHRAE EXTREME LOW: -6.4°CASHRAE 2% HIGH: 35°CWIND SPEED: 110 MPH (ASCE7-10)RISK CATEGORY: IIWIND EXPOSURE CATEGORY: BGROUND SNOW LOAD: 10 PSF

NE HALSEY ST-CLACKAMAS ST ALLEY

NE

25T

H A

VE

1. PV SYSTEMS AND SUPPORTING STRUCTURE SHALL COMPLYWITH REQUIREMENTS OF 2017 OESC & 2014 OSSC.

2. 3111.3.2 - PV RACKING AND ATTACHMENTS SHALL BE UL 1703CERTIFIED.

3. 3111.3.4 - PV SYSTEM SHALL HAVE A FIRE CLASSIFICATION THATIS EQUAL TO OR GREATER THAN THE ROOF ASSEMBLYREQUIRED BY OSSC SECTION 1505.1.

4. 3111.4.3 - 3111.4.7- PV LAYOUT SHALL NOT RESTRICT EGRESS,LIGHT VENTILATION, OR ROOF DRAINAGE REQUIREMENTS.

5. 3111.4.8.1 - GENERAL PATHWAY REQUIREMENTS:

36" WIDE PATHWAY SHALL NOT BE REQUIRED ON STRUCTURESWITH A PV ARRAY AREA OF 1,000 SF OR LESS INSTALLED ON AROOF WITH A SLOPE THAT EXCEEDS 2:12 AND WITH ANINTERSECTING ADJACENT ROOF AND WHERE NO SECTION ISLARGER THAN 150 FEET MEASURED IN LENGTH OR WIDTH.

WHERE PV ARRAY DOES NOT EXCEED 25% AS MEASURED INPLAN VIEW OF TOTAL ROOF AREA OF A STRUCTURE, A MINIMUMOF 12" UNOBSTRUCTED PATHWAY SHALL BE MAINTAINED ALONGEACH SIDE OF ANY HORIZONTAL RIDGE.

WHERE THE SOLAR ARRAY EXCEEDS 25% AS MEASURED IN PLANVIEW OF TOTAL ROOF AREA OF THE STRUCTURE, A MINIMUM OFONE 36" UNOBSTRUCTED PATHWAY SHALL BE PROVIDED INADDITION TO A MINIMUM 12" UNOBSTRUCTED ALONG EA. SIDEOF ANY HORIZONTAL RIDGE.

6. ROOF STRUCTURE IS CONVENTIONAL LIGHT FRAMED WOODCONSTRUCTION WITH 2X4 MANUFACTURED TRUSSES @ 24" O.C.REFER TO ALLOWABLE SPAN REQUIREMENTS IN TABLE 305.4.1.

7. 3111.4.8.5.1 - DISCONNECTS, J-BOXES, COMBINER BOXES ORGUTTERS SHALL NOT BE PLACED IN ANY REQUIRED PATHWAYOR CUTOUT.

8. 3111.5.3.1 - TOTAL SYSTEM WEIGHT SHALL NOT EXCEED 4.5 PSF.PV MODULES AND RACKING SHALL BE DIRECTLY ATTACHED TOROOF FRAMING AS SHOWN IN PV-2. ATTACHMENT SPACING WILLBE 48" O.C. MAX, AND WHEN ATTACHMENT LOCATED WITHIN 3'OF ROOF EDGE, HIP, EAVE, RIDGE SHALL BE 24" O.C. MAX.

9. 3111.5.4 - MAX MODULE HEIGHT < 18" OFF ROOF SURFACE.

FRAMING PLAN

PV-2

CONTRACTOR


Page:

Rev:

Ph:Ph:



(971)-240-7102


4.56 kW 4.67 kW




(971)-240-7102

ANY INSTALLER

FRAMING CROSS SECTIONSCALE: N.T.S.

2X4 RAFTERS@ 24" O.C.

3' SETBACK

S

W

N

E

PV MODULE

SEE MOUNTING DETAILSUNMODO HELIO HR150

RAIL & EZ ROOF MOUNT KITW/STANDOFF

LEGEND:

FRAMING PLANSCALE: 1/8" = 1'-0"

EZ ROOF MOUNT KIT W/STANDOFFSPAN ~4FT. TO MEET

ASCE 7-10 WITH WIND

SPEED AT 110 MPH

EZ ROOF MOUNT KIT W/STANDOFFSPAN ~24" TO MEET

ASCE 7-10 WITH WIND

SPEED AT 110 MPH

33'-1"

19'-1

1"

LOW PROFILE ROOFPROTRUSION, TYP.

SUNMODOHELIO HR150 RAIL

5/16"x4.5" LAGSCREW WITH2.5" MIN.EMBEDMENT

COMPOSITESHINGLEROOFING

SUNMODO 3"STANDOFF

PV MODULE

2X4 RAFTERS@ 24" O.C.

MOUNTING DETAIL WITH STANDOFFSCALE: N.T.S.

30°

1

2

30°

1

1

1

12

30°

2

2

30°

1

RIDGE

EAVE

EAVE

2X4 RAFTERS @ 24" O.C.

16'-7"

43'-7

"

FLASHING

ELECTRICAL PLAN

PV-3

CONTRACTOR


Page:

Rev:

Ph:Ph:



(971)-240-7102


4.56 kW 4.67 kW




(971)-240-7102

ANY INSTALLER

S

W

N

E

NON-FUSED ACDISCONNECT(EXTERIOR WALL)

(E) METER(EXTERIOR WALL)

(N) IQ ENVOY(EXTERIOR WALL)

IQ6-60-2-US MICROINVERTERS ARELOCATED UNDERSIDEOF EACH MODULESAND ARE INSTALLEDTO CONTINUOUSSUPPORT RAIL.

BR

AN

CH

# 1

(8

MO

DS

)

3/4" EMT

25'-1"

GENERAL NOTES:

1. CONDUIT IS DIAGRAMMATIC. FINAL ROUTING TO BEDETERMINED BY INSTALLER.

2. SUNEYE SHOTS S1, S2, AND S3 WERE COLLECTED INTHE SPECIFIED LOCATIONS.

3. SUNEYE SHOT S1 ON LOWER ROOF CORRESPONDSTO "DOROCHER RESIDENCE SHADE REPORT -LOWER ROOF" PDF.

4. SUNEYE SHOTS S1 AND S3 ON UPPER ROOFCORRESPONDS TO "XXX RESIDENCE SHADEREPORT - UPPER ROOF" PDF

ELECTRICAL PLANSCALE: 1/8" = 1'-0"

(E) PANEL(INTERIOR WALL)

S3

S1

S2

SOLARWORLD SW 295MONO MODULES

KYOCERA KD210GX-LPUMODULES

BRANCH # 2 (11 MODS)

32'-5

"

EXISTING AC DISTRIBUTION PANEL

120/240V, 1P, 3W

200A WITH

200A MAIN BREAKER3/4" EMT OR EQUIVALENT:(2) #10 AWG THWN-2 CONDUCTORS(1) #10 AWG THWN-2 GROUND

GROUND

NEUTRAL

METER

200A

LOCKABLE, NON-FUSEDAC DISCONNECT30A, 240V, 2-POLE

B

BM

D

O

C

25A

BRANCH TERMINATORQ-TERM-10 (TYP.)

ENPHASE Q CABLE (TYP.)BLACK - L1RED - L2

JUNCTION BOX (TYP.)

GROUND

A

A

LAY IN LUG

RAIL

LAY IN LUG

RAIL10A

15A

BRANCH CIRCUIT #2

(11) KYOCERA KD210GX-LPU

MODULES

(11) MICRO-INVERTERS

@ 240V VAC

ENPHASE IQ6-60-2-US

BRANCH CIRCUIT #1

(8) SOLARWORLD SW 295

MONO MODULES

(8) MICRO-INVERTERS

@ 240V VAC

ENPHASE IQ6-60-2-US

3/4" CONDUIT:(2) #10 AWG THWN-2 CONDUCTORS

(1) #10 AWG THWN-2 GROUND

3/4" CONDUIT:(2) #10 AWG THWN-2 CONDUCTORS

(1) #10 AWG THWN-2 GROUND

PATCH CABLE TONETWORK ROUTER

60A IQ ENVOY, NEMA-3R,

120/240V, 1ɸ

EXISTING 120VOUTLET

IQ ENVOY

25A

P

THREE LINE DIAGRAM

PV-4

GENERAL NOTES:

1. CONTRACTOR RESPONSIBLE FOR COMPLYING WITHALL LOCAL OR NATIONAL CODE REQUIREMENTS ANDEQUIPMENT INSTALLATION INSTRUCTIONS.

2. SEE PV-5 FOR LABELING REQUIREMENTS

WIRE RUN # OF MODS V (VOLTS) I (AMPS) L (FT) VD VD (%) WIRE SIZE RACEWAY

VOLTAGE DROP CALCULATIONS

BRANCH 1 8 240V 7.67A 53 0.9V 0.37% 12 AWG Q CABLE FREE AIR

BRANCH 2 11 240V 10.54A 72 1.64V 0.68% 12 AWG Q CABLE FREE AIR

BRANCH 1 HOMERUN 8 240V 7.67A 30 0.57V 0.24% 10 AWG THWN-2 3/4" EMT

MAX. POWER Pmax 240 W

MAX. INPUT VOLTAGE 48 V

SW 295 MONO Voc @ -6.4°C 43.8 V

43.8V < 48V YES

KD210GX-LPU Voc @ -6.4°C 36.6 V

36.6V < 48V YES

OUTPUT CURRENT 0.96 A

OUTPUT VOLTAGE 240 V, 1ɸDC/AC RATIO 1.23 & 0.88

INVERTER SPECS

CONTRACTOR


Page:

Rev:

Ph:Ph:



(971)-240-7102


4.56 kW 4.67 kW




(971)-240-7102

ANY INSTALLER

BRANCH 2 HOMERUN 11 240V 10.54A 56 1.47V 0.61% 10 AWG THWN-2 3/4" EMT

IQ ENVOY 19 240V 18.24A 10 0.45V 0.19% 10 AWG THWN-2 3/4" EMT

MAX VOLTAGE DROP: 1.48%

CALCULATIONS NOTES: *WIRE SIZES INCLUDE DE-RATING FACTORS SUCH AS AMBIENT TEMPERATURE AND MORE THAN 3CURRENT CARRYING CONDUCTORS IN CONDUIT.

MODULE MAKE SOLARWORLD

MODULE MODEL SW 295 MONO

MAX. POWER Pmax 295 W

OPEN CIRCUIT VOLTAGE Voc 40 V

MAX. POWER POINT Vmp 31.4 A

SHORT CIRCUIT CURRENT Isc 10.1 A

MAX. POWER POINT Imp 9.45 A

Voc TEMP. COEFF. -0.30%/°C

Pmax TEMP. COEFF. -0.42%/°C

MODULE SPECS

KYOCERA

KD210GX-LPU

210 W

33.2 V

31.4 A

8.58 A

7.9 A

-0.33%/°C

-0.43%/°C

X

WARNING - PHOTOVOLTAIC

POWER SOURCE

LABEL EVERY 10'

CAUTION SOLAR CIRCUIT

LABEL EVERY 10'

CAUTION: SOLAR ELECTRIC

SYSTEM CONNECTED

DUAL POWER SUPPLY

SOURCES: UTILITY GRID ANDSOLAR PHOTOVOLTAIC SYSTEM

WARNING

M

OPERATING AMPS 18.24AOPERATING VOLTAGE 240V

ELECTRIC SHOCK HAZARDWARNING

AC DISCONNECT

LOCATION: MAIN AC DISCONNECT

PHOTOVOLTAIC SYSTEM

DO NOT TOUCH TERMINALS

TERMINALS ON BOTH LINE AND

LOAD SIDE MAY BE ENERGIZED IN

THE OPEN POSITION

LOCATION: MAIN SERVICE PANEL

LOCATION: MAIN SERVICE PANEL

SOLAR PV SYSTEM EQUIPPEDWITH RAPID SHUTDOWN

TURN RAPID SHUTDOWN

SWITCH TO THE "OFF"

POSITION TO SHUT DOWN

PV SYSTEM AND REDUCE

SHOCK HAZARD IN THE

ARRAY

NEC 2017 690.12, 690.56(C)(1)(a)

LABEL FOR PV SYSTEMS THAT SHUT DOWN THE ARRAY AND

THE CONDUCTORS LEAVING THE ARRAY.

NOTE: THE LABEL SHALL UTILIZE CAPITALIZED

CHARACTERS WITH A MINIMUM HEIGHT OF 3/8" IN BLACK

ON YELLOW BACKGROUND, AND THE REMAINING

CHARACTERS SHALL BE CAPITALIZED WITH A MINIMUM

HEIGHT OF 3/16" IN BLACK ON WHITE BACKGROUND.

A

B

C

D

P

LOCATION: BUILDING MAIN SERVICE PANEL

CAUTION

POWER TO THIS BUILDING IS SUPPLIED FROM THEFOLLOWING SOURCES WITH DISCONNECTS LOCATED ASSHOWN:

INPUT RATINGS

ELECTRIC SHOCK HAZARDWARNING

DO NOT TOUCH TERMINALS

TERMINALS ON BOTH LINE AND

LOAD SIDE MAY BE ENERGIZED IN

THE OPEN POSITION

O

N

LABELS

PV-5

CONTRACTOR


Page:

Rev:

Ph:Ph:



(971)-240-7102


4.56 kW 4.67 kW




(971)-240-7102

ANY INSTALLER

SERVICEDISCONNECT

PV ACDISCONNECT

SOLAR ARRAYS

AC DISCONNECT IS THE

RAPID SHUTDOWN SWITCH

Documents

SAMPLE RESIDENCE - Avila Solar · 2019. 10. 24. · 8. 3111.5.3.1 - total system weight shall not exceed 4.5 psf. pv modules and racking shall be directly attached to roof framing