Embed Size (px)
Citation preview
ROSATOM
INPRO Dialog-Forum
13-15.04.2016, IAEА, VIENNA, AUSTRIA
State Atomic Energy Corporation “Rosatom”
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information. 2
Material engineering:
material testing
& fuel studies
Space explorationMedicineApplied science and education
Nuclear energy:
Generation IV technologies,
closed fuel cycle, minor
actinides management
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information. 3
Most operative material testing high flux research reactors
will exceed 50 years lifetime by 2020
Some Operating
Research Reactors in
Europe
Power, MW
Max. Fast Neutron Flux,
1015 n/(cm2�s)
Age
by 2020,
years
LVR-15 (CZ) 10 0.3 63
HBWR (NOR) 20 0.08 61
BR-2 (B) 100 0.7 59
HFR (NL) 45 0.5 59
MARIA (PO) 30 0.1 46
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information.
Rotary Plug
Plug Drive
Vessel
Vertical
Experimental
Channels
Horizontal
Experimental
Channels
Reactor
Core
Loop
Channel
ROSATOM starts construction of a new unique research
fast neutron reactor facility
State Atomic Energy Corporation “Rosatom” and
Scientific and Research Institute of Atomic Reactors (RIAR)
present MBIR - a Multipurpose Sodium Fast Research Reactor
150 MW thermal, 55 MW electric power
Maximum neutron flux 5.3·1015 n/(cm2·s)
Aggregate annual irradiation capacity – over 1300 dpa*dm3
MOX fuel
Closed fuel cycle
Upgradeable experimental capabilities: loops, irradiation devices,
instrumented channels, neutron beams
Designed life time 50 years
Target commissioning by the end of 2019
Unique experience and staff resources of RIAR
Supporting on-site laboratory complex and infrastructure
4Ultimate mission — enhancement of international R&D infrastructure
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information.
Hot Cells &
PIE Complex
Cooling pools & SNF
handling facilities Outside Loop Channels
auxiliary equipment boxes
Labs & Offices
5
MBIR is a technically advanced successor to BOR-60
BOR-60 (60 MW) - the only
fully operative fast research reactor
The cutting-edge self-sufficient R&D Complex
based on MBIR reactor
BOR-60 MBIR
Max. neutron flux, 1015 sec-1 cm-2 2.8 5.3
MTA’s in the core 12 14
Number of instrumented cells 1 3
Outside loop channels 0 3
Vertical and horizontal channels 12 18
Max. dpa rate in a channel 22 34
Aggregate annual irradiation capability (dpa*dm3) 300 1300
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information.
Alternatives to BOR60 and MBIR are limited
ROSATOM decision to develop the MBIR based research center as an international
project opens up a unique opportunity to preserve, update and extend the research
infrastructure for the nuclear applied science in its quest for reliable, safe and
sustainable energy solutions
6
IN RUSSIA
� BN-600 - commercial FR
� BN-800 - commercial FR
IN THE WORLD
� CEFR - prototype reactor, not
equipped for research
� FBTR - low powered
� Monju & Joyo - shut down
� FFTF - shut down
� MYRRHA - under consideration
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information.7
Planned/
DesignedMW Max neutron flux
Under
construction MW Max neutron flux
Vietnam 15 5,0 x 1014 Jordan (JRTR) 5 1,5 x 1014
Belarus 20 5,0 x 1014 Brazil (RMB) 30 2,0 x 1014
India (HFRR) 30 6,7 x 1014Republic of Korea
(KJRR)15 3,0 x 1014
The Netherlands
(PALLAS) 55 n/a Argentina (RA10) 30 3,0 x 1014
Belgium (MYRRHA
fast)85 *1,0х1015 France (JHR) 100
*1.0 х 1015
5.5 x 1014
Russian Federation
(MBIR fast)150 5,3 x 1015
MBIR has the highest flux amongst all new research reactors
designed or under construction
* fast neutron flux
per IAEA database and public sources
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information. 8
.
ROSATOM / RIARInternational Research Center
MBIR
Single (Collective User)
R&D program management
Joint activities
Reactor services marketing and PR
Funding management
IP service
Technical services
Financial supportB
Owner & Operator
Operating the reactor
Liabilities, operation & maintenance
R&D program execution
Laboratory assist
ROSATOM encourages international cooperation
within IRC MBIR
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information.9
International MBIR concept history started in 2010
February, 2010 - Federal program for the development
of innovative nuclear technologies for the period
up to 2020 is set up
September, 2010 – MBIR project international format
is announced at the 54th IAEA General Conference
by Rosatom CEO Sergei Kirienko
September, 2014 – MBIR IRC concept
confirmed at the 58th IAEA General Conference
by Rosatom Deputy General
Vyacheslav Pershukov
November, 2014 – international seminar in St.Petersburg
June, 2015 - Atomexpo-2015 in Moscow
G
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information. 10
IRC MBIR: Participation and Flux Share
Forms of participation at different stages with different
commitments:
• Participants
• Contractual users
• Multilateral programs
Flux share:
• Used for the own participant’s program(s)
• Merged with other participants
• Swapped in time for successive periods
• Leased to other participants or one-time users
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information.
IRC MBIR Management
Steering Committee
Strategic management
Research program approval
Audit & control
Advisory Board
Research program drafting
Review & short listing
Reactor Operator
IRC Management • Operator (RIAR) liaison
• Investors coordination & reporting
• Financial management
• Investment management
Participants
Advisory Board:
• Participants representatives
• Operator representatives
• Representatives of contractual users
and multilateral research collaborations
• Independent advisers and experts
11
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information. 12
Interested parties Key research areas, trends
Nuclear power plants
operators
NPP life extension. Addressing issues of embrittlement, swelling
and residual stress
Designers seeking novel
technology
INPRO, Generation IV, European Sustainable Nuclear Industrial
Initiative
Fusion reactor community Appropriate materials and referential testing
Materials scientists,
metallurgists, chemists
New materials testing with high dosage irradiation
Isotopes producers Development for new effective isotopes
Semiconductor industry Large irradiation channels diameter
NPP life extension
Fuel efficiency improvement
New materials
Small Modular Reactors
Isotopes research and irradiation
Silicon doping
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information.13
MBIR first concrete in September 2015
October, 2013 – Basic design of MBIR facility
March, 2014 – State project expertise
July, 2014 – Site license
September, 2014 – Environmental assessment
November, 2014 – Contract for civil works with Uralenergostroy
May, 2015 – Construction license
September, 2015 – First concrete
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information.
Project is within time schedule
Design
MBIR constructionMBIR
commissioning
Expertise
Design
optimization
RPV & vessel internals
installationFirst criticality
Site license
20192013 2014 2016 20172015 20182012
MBIR R&D MBIR equipping
2020
14
Construction license
Licensing
First concrete
BOP & auxiliary buildings
Experimental loops & channels
Hot cells equipment
Main reactor building with auxiliaries
RPV & reactor internals
Fuel manufacturing
Physical security system
����
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information.15
Unique instrument for Generation IV technologies:
• Access to the highest fast neutron flux
• Operator with outstanding reactor management skills
• Knowledge sharing
• Saving on the national RR infrastructure required
IRC MBIR for Generation IV
In channel/In loop In core
MBIR: Material /Fuel Investigation
VHTR
SFR
MSR
LFR
GFR
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information. 16
Contact Persons:
Alexander Zagornov
IRC MBIR Project Manager
+7 (499) 949-40-75
Olga Korchagina
IRC MBIR Project coordinator
+7 (499) 949-40-26
To Join IRC MBIR today
The content of this presentation is for discussion purposes only, shall not be considered as an offer and doesn’t lead to any obligations to ROSATOM
and its affiliated companies. ROSATOM disclaims all responsibility for any and all mistakes, quality and completeness of the information.
Thank you for your attention!
17
