Embed Size (px)
Citation preview
REPLACEMENT PARTS FOR
CARRIER®
THERMO-KING®
REFRIGERATION UNITS
EVERSTRAIGHT INDUSTRIAL CO., LTD. 2F, NO. 82, KEJI 3RD ROAD, TAINAN 709, TAIWAN TEL: +886-6-384-1237 FAX: +886-6-384-1219 E-mail : [email protected] [email protected]
Website : www.everstraight.com.tw
THERMO KING® is a registered trademark of Thermo King Corporation; CARRIER® is a registered trademark of Carrier Corporation –
Everstraight is not affiliated with Thermo King Corporation and Carrier Corporation.
- 2 -
MODELS PAGE ENGINE COMPONENTS
THERMO-KING ISUZU C201 3-4
ISUZU 2.2D.I. & 2.2 S.E. 5-6
YANMAR 235 7
YANMAR 353 8
YANMAR 244 & 2NT66 9
YANMAR 366 10
YANMAR 374 11
YANMAR 388 12
YANMAR 395 13
YANMAR 482 14-15
YANMAR 486 16-17
CARRIER-TRANSICOLD KUBOTACT4-114 18
KUBOTACT4-114 d.i. 19
KUBOTACT4-133 d.i. 20
KUBOTACT4-134 d.i. 21
KUBOTACT4-134 t.v. 22
KUBOTACT3-44 t.v.. 23
COMPRESSOR PARTS THERMO-KING
214 24
214D 25
426 26
X426 27
X430 28
CARRIER-TRANSICOLD
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
(2019.02.13)
TABLE OF CONTENTS
- 3 -
ISUZU C201 4CYL
EVERSTRAIGHT NO.
REF TK. # DESCRIPTION NOTE
1002-10046 11-4848P PISTON W/PIN&CLIP-STD (CYL)
1002-10046-1 11-4849P PISTON W/PIN&CLIP-.010”(CYL)
1002-10046-2 11-4850P PISTON W/PIN&CLIP-.020”(CYL)
1002-10046-3 11-5686P PISTON W/PIN&CLIP-.030”(CYL)
1002-10046-4 11-4851P PISTON W/PIN&CLIP-.040”(CYL)
1009-10046 11-4848 PISTON W/PIN&CLIP&RING-STD(CYL)
1009-10046-1 11-4849 PISTON W/PIN&CLIP&RING-.010”(CYL)
1009-10046-2 11-4850 PISTON W/PIN&CLIP&RING-.020”(CYL)
1009-10046-3 11-5686 PISTON W/PIN&CLIP&RING-.030”(CYL)
1009-10046-4 11-4851 PISTON W/PIN&CLIP&RING-.040”(CYL)
1003-11014 11-4744/8078 RING SET, STD (CYL)
1003-11014-1 11-4745/8079 RING SET, .010”(CYL)
1003-11014-2 11-4746/8080 RING SET, .020”(CYL)
1003-11014-3 11-5687 RING SET, .030”(CYL)
1003-11014-4 11-4747/8081 RING SET, .040”(CYL)
1008-09025 11-7043 SLEEVE,CYLINDER (CYL)
1050-08041 11-4785 MAIN BEARING SET, STD(10PCS)
1050-08041-1 11-4786 MAIN BEARING SET, .010”(10PCS)
1050-08041-2 11-4784 MAIN BEARING SET, .020” (10PCS)
1051-08041 11-5744 CON. ROD BEARING SET,STD(4PAIRS)
1051-08041-1 11-5745 CON. ROD BRG SET, .010”(4PAIRS)
1051-08041-2 11-5746 CON. ROD BRG SET, .020”(4PAIRS)
1053-08038 11-3404 THRUST WASHER SET, STD (2PCS)
1052-08024 11-3845 CAM BEARING SET(3PCS)
1005-08039 11-3418 PIN BUSHING SET, STD(4PCS)
11-5338 OIL PUMP ASSEMBLY
11-4576 WATER PUMP ASSEMBLY
1016-09006 11-2727 VALVE, INTAKE(PC)
1016-09007 11-2719 VALVE, EXHAUST(PC)
1026-11020 11-3374 VALVE GUIDES, INTAKE(PC)
1026-11021 11-3375 VALVE GUIDES, EXHAUST(PC)
1090-13005 11-3439 TAPPET
1056-12034 30-175 OVERHAUL GASKET SET
1029-11002 33-792 HEAD GASKET
1018-08016 33-2535/2055 OIL SEAL, REAR (PC)
1018-08017 33-2534/2207 OIL SEAL, FRONT (PC)
30-197 SPEEDI-SLEEVE (PC)
- 4 -
ISUZU C201 4CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
7099-10047 10-258 FREEZE PLUG SET, BLOCK
7099-10046 10-259 FREEZE PLUG SET,HEAD
44-4774 OIL PRESSURE SWITCH (PC)
2503-09036 44-2922 GLOW PLUG (PC)
1099-12001 11-4564 HOSE, BY PASS (PC)
1070-12001-1 11-3365 NOZZLE,INJECTION (PC)
7099-12010 11-2725 PRIMER PUMP ASSEMBLY (PC)
1027-13001 11-4414 VALVE STEM SEAL SET (VITON)
1099-12005 11-6845 SPEEDI-SLEEVE, FRONT
1099-12002 11-7259/4254 SPEEDI SLEEVE, REAR
1080-13006 11-3431 CAMSHAFT
1039-12034 33-1059 GASKET, MANIFOLD
7058-09001 11-7702 THERMOSTAT
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 5 -
ISUZU 2.2 d.i. 4CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
1002-10098 11-5900P PISTON W/PIN&CLIP-STD
1002-10098-1 11-5901P PISTON W/PIN&CLIP-.010”
1002-10098-2 11-5902P PISTON W/PIN&CLIP-.020”
1002-10098-3 11-5903P PISTON W/PIN&CLIP-.030”
1002-10098-4 11-5904P PISTON W/PIN&CLIP-.040”
1009-10098 11-5900 PISTON W/PIN&CLIP&RING-STD
1009-10098-1 11-5901 PISTON W/PIN&CLIP&RING-.010”
1009-10098-2 11-5902 PISTON W/PIN&CLIP&RING-.020”
1009-10098-3 11-5903 PISTON W/PIN&CLIP&RING-.030”
1009-10098-4 11-5904 PISTON W/PIN&CLIP&RING-.040”
1003-13001 11-8082/5819 RING SET, STD
1003-13001-1 11-8083/5820 RING SET, .010”
1003-13001-2 11-8084/5821 RING SET, .020”
1003-13001-3 11-5822 RING SET, .030”
1003-13001-4 11-8085/5823 RING SET, .040”
1050-10031 11-5806 MAIN BEARING SET, STD (10PCS)
1050-10031-1 11-5807 MAIN BEARING SET, .010” (10PCS)
1050-10031-2 11-5808 MAIN BEARING SET, .020” (10PCS)
1050-10031-3 11-5809 MAIN BEARING SET, .030” (10PCS)
1050-10031-4 11-5810 MAIN BEARING SET, .040” (10PCS)
1051-10032 11-5826 CON. ROD BEARING SET,STD (4PAIRS)
1051-10032-1 11-5827 CON. ROD BEARING SET, .010” (4PAIRS)
1051-10032-2 11-5828 CON. ROD BEARING SET, .020” (4PAIRS)
1051-10032-3 11-5829 CON. ROD BEARING SET,.030” (4PAIRS)
1051-10032-4 11-5830 CON. ROD BEARING SET, .040” (4PAIRS)
1053-08135 11-5811 THRUST WASHER SET, STD (2PCS)
1052-08089 11-5785 CAM BEARING SET (3PCS)
1005-10032 11-5825 PIN BUSHING SET, STD (4PCS)
11-6017 OIL PUMP ASSEMBLY
11-5858 USE 11-8096
7023-10001 11-8096 WATER PUMP ASSEMBLY
11-2207 USE 33-2534
1016-12022 11-5850 VALVE, INTAKE
1016-12023 11-5851 VALVE, EXHAUST
1026-12002 11-5779 VALVE GUIDE, IN. & EX.
7027-23001 11-5847 SPRING, VALVE
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 6 -
ISUZU 2.2 d.i. 4CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
1099-12003 11-5833 WEAR RING, CRANKSHAFT REAR
7056-12030 30-177 OVEHAUL GASKET SET
7029-12030 33-1627 GASKET, CYLINDER HEAD
1099-13001 11-5861 HOSE, BY PASS
1018-23001 33-2534 OIL SEAL, FRONT
1018-13001 33-2208 OIL SEAL, REAR
7099-10099 10-275 FREEZE PLUG SET, BLOCK
7099-10098 10-276 FREEZE PLUG SET,HEAD
2503-12006 44-6601 GLOW PLUG
7081-11002 11-6873 CONNECTING ROD
7058-09001 11-7702 THERMOSTAT
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 7 -
YANMAR 235 2CYL
EVERSTRAIGHT
NO REF TK. # DESCRIPTION NOTE
1002-10093 11-5248P PISTON W/PIN&CLIP-STD
1009-10093 11-5248 PISTON W/PIN&CLIP&RING-STD
7008-12201 11-5002 LINER
1003-10093 11-5106 RING SET, STD
1050-10093 11-5245 MAIN BEARING SET, STD (2PCS)
1050-10093-1 11-5246 MAIN BEARING SET, .010” (2PCS)
1051-10093 11-5043 CON. ROD BEARING ,STD (PAIR)
1051-10093-1 11-5195 CON. ROD BEARING , .010” (PAIR)
1052-10093 11-5484 CAM BEARING
1005-10093 11-5459 PIN BUSHING , STD
11-5436 WATER PUMP ASSEMBLY
1016-10093 11-5011 VALVE, INTAKE
1016-10096 11-5012 VALVE, EXHAUST
1026-10093 11-5016 VALVE GUIDES, INTAKE
1026-10096 11-5017 VALVE GUIDES, EXHAUST
7056-12021 30-174 OVERHAUL GASKET SET
7099-10093 10-262 FREEZE PLUG SET(5PCS)
11-5028 BEARING, BALL(CAM)
11-5488 OIL PUMP ASSEMBLY
1099-12006 11-5966 REPAIR SLEEVE, FRONT
1099-12007 11-5967 REPAIR SLEEVE, REAR
1018-13003 33-1506 OIL SEAL, REAR
1018-10093 33-1509 OIL SEAL, FRONT
1503-10093 44-4728 GLOW PLUG
1503-10094 44-5810 GLOW PLUG
11-7894 THERMOSTAT
7058-09002 11-9621 THERMOSTAT
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 8 -
YANMAR 353 3CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
1002-10093 11-5248P PISTON W/PIN&CLIP-STD
1009-10093 11-5248 PISTON W/PIN&CLIP&RING-STD
7008-12201 11-5002 LINER
1003-10093 11-5106 RING SET, STD
1050-10093 11-5245 MAIN BEARING SET, STD (4PCS)
1050-10093-1 11-5246 MAIN BEARING SET, .010” (4PCS)
1050-10094 11-5182 MAIN BEARING , STD (PAIR)
1050-10094-1 11-5367 MAIN BEARING , .010” (PAIR)
1051-10093 11-5043 CON. ROD BEARING ,STD (PAIR)
1051-10093-1 11-5195 CON. ROD BEARING , .010” (PAIR)
1052-10093 11-5484 CAM BEARING
1005-10093 11-5459 PIN BUSHING, STD
11-5436 WATER PUMP ASSEMBLY
1016-10093 11-5011 VALVE, INTAKE
1016-10096 11-5012 VALVE, EXHAUST
1026-10093 11-5016 VALVE GUIDES, INTAKE
1026-10096 11-5017 VALVE GUIDES, EXHAUST
7056-12020 30-173 OVERHAUL GASKET SET
7099-10094 10-263 FREEZE PLUG SET(6PCS)
11-5028 BEARING, BALL(CAM)
11-5488 OIL PUMP ASSEMBLY
1099-12006 11-5966 REPAIR SLEEVE, FRONT
1099-12007 11-5967 REPAIR SLEEVE, REAR
1018-13003 33-1506 OIL SEAL, REAR
1018-10093 33-1509 OIL SEAL, FRONT
1503-10093 44-4728 GLOW PLUG
1503-10094 44-5810 GLOW PLUG
11-7894 THERMOSTAT
7058-09002 11-9621 THERMOSTAT
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 9 -
YANMAR 244 2CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
1002-10091 11-7022P PISTON W/PIN&CLIP-STD
1002-10091-1 11-7023P PISTON W/PIN&CLIP-.010”
1002-10091-2 11-7024P PISTON W/PIN&CLIP-.020”
1009-10091 11-7022 PISTON W/PIN&CLIP&RING-STD
1009-10091-1 11-7023 PISTON W/PIN&CLIP&RING-.010”
1009-10091-2 11-7024 PISTON W/PIN&CLIP&RING-.020”
1003-10091 11-6072 RING SET, STD
1003-10091-1 11-6073 RING SET, .010”
1003-10091-2 11-6023 RING SET, .020”
1050-10091 11-6026 MAIN BEARING , STD (PAIR)
1050-10091-1 11-6027 MAIN BEARING , .010” (PAIR)
1051-10091 11-6077 CON. ROD BEARING ,STD (PAIR)
1051-10091-1 11-6079 CON. ROD BEARING , .010” (PAIR)
1053-10091 11-6028 THRUST WASHER SET, STD (2PCS)
1052-10091 11-6033 CAM BEARING
1005-10091 11-6078 PIN BUSHING , STD
1016-10091 11-6039 VALVE, INTAKE
1016-10094 11-6040 VALVE, EXHAUST
1026-10091 11-6038 VALVE GUIDES, INTAKE & EXHAUST
7056-12024 30-183 OVERHAUL GASKET SET
7008-12202 11-6874 SPEEDI-SLEEVE
1503-10095 44-7130 GLOW PLUG
11-6090 WATER PUMP ASSEMBLY
1018-13003 33-1506 OIL SEAL, REAR
1018-13002 33-1727 OIL SEAR, FRONT
1027-10093 33-1732 VALVE STEM SEAL SET
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 10 -
YANMAR 366 3CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
1002-10091 11-7022P PISTON W/PIN&CLIP-STD
1002-10091-1 11-7023P PISTON W/PIN&CLIP-.010”
1002-10091-2 11-7024P PISTON W/PIN&CLIP-.020”
1009-10091 11-7022 PISTON W/PIN&CLIP&RING-STD
1009-10091-1 11-7023 PISTON W/PIN&CLIP&RING-.010”
1009-10091-2 11-7024 PISTON W/PIN&CLIP&RING-.020”
1003-10091 11-6072 RING SET, STD
1003-10091-1 11-6073 RING SET, .010”
1003-10091-2 11-6023 RING SET, .020”
1050-10091 11-6026 MAIN BEARING , STD (PAIR)
1050-10091-1 11-6027 MAIN BEARING , .010” (PAIR)
1051-10091 11-6077 CON. ROD BEARING ,STD (PAIR)
1051-10091-1 11-6079 CON. ROD BEARING , .010” (PAIR)
1053-100091 11-6028 THRUST WASHER SET, STD (2PCS)
1052-10091 11-6033 CAM BEARING
1005-10091 11-6078 PIN BUSHING, STD
1016-10091 11-6039 VALVE, INTAKE
1016-10094 11-6040 VALVE, EXHAUST
1026-10091 11-6038 VALVE GUIDES, INTAKE & EXHAUST
7056-12022 30-180 OVERHAUL GASKET SET
7056-12022A 33-1726 HEAD GASKET, CYL
7099-10091 10-265 FREEZE PLUG SET,BLOCK (9PCS)
7099-10095 10-264 FREEZE PLUG SET, HEAD (2PCS)
1503-10095 44-7130 GLOW PLUG
11-6090 WATER PUMP ASSEMBLY
11-6133 OIL PUMP ASSEMBLY
1018-13003 33-1506 OIL SEAL, REAR
1018-13002 33-1727 OIL SEAR, FRONT
1027-10093 33-1732 VALVE STEM SEAL SET
11-6092 USE ES11-7975
7058-09003 11-7975 THERMOSTAT
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 11 -
YANMAR 374 3CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
7099-09002 10-374FPB FREEZE PLUG SET, BLOCK
7099-09004 10-374FPH FREEZE PLUG SET, HEAD
1050-10091 11-6026 MAIN BEARING, STD (PAIR)
1050-10091-1 11-6027 MAIN BEARING, 0.25MM (PAIR)
1053-10091 11-6028 THRUST WASHER SET, STD (2 PCS)
1052-10091 11-6033 CAM BEARING SET
1016-10091I 11-6039 VALVE, INTAKE
1016-10091E 11-6040 VALVE, EXHAUST
7027-09007 11-6047 ROCKER ARM, INTAKE
7027-09005 11-6048 ROCKER ARM, EXHAUST
11-6075 CONNECTING ROD
1051-10091 11-6077 CON. ROD BRG, STD (PAIR)
1051-10091-1 11-6079 CON. ROD BRG, 0.25MM (PAIR)
1005-10091 11-6078 PIN BUSING, STD
11-6102 INJECTOR NOZZLE
7025-09004 11-6133 OIL PUMP
11-7031 RING GEAR, FLYWHEEL
7058-09003 11-7975 THERMOSTAT , WATER
7003-09001 11-8644 RING SET, STD
7026-09002 11-8741 GUIDE, VALVE
7009-09001 11-8751 PISTON ASSEMBLY(W/ RING) - STD
7001-09001 11-8751P PISTON W/PIN & CLIP - STD
7009-09001-1 11-8754 PISTON ASSEMBLY(W/ RING) – 0.25MM
7001-09001-1 11-8754P PISTON W/PIN & CLIP – 0.25MM
7003-09001-1 11-8755 RING SET, 0.25MM
11-8769 INJECTOR ASSEMBLY
7509-09002 11-9496 WATER PUMP
30-0235 USE 30-235
7056-09001 30-235 OVERHAUL GASKET SET
1018-13003 33-1506 OIL SEAL, REAR MAIN
1018-13002 33-1727 OIL SEAL, FRONT
1027-10093 33-1732 SEAL, VALVE STEM
33-1733 GASKET, NOZZLE
7029-09001 33-2738 GASKET, HEAD
41-2330 SENSOR, WATER TEMPERATURE
41-387 SWITCH, OIL PRESSURE (NON SR UNITS)
41-402 SWITCH, OIL LEVEL
1503-10095 44-7130 GLOW PLUG
44-8883 SWITCH, OIL PRESSURE (SR UNITS)
45-1718 STARTER
7058-09003 11-7975 THERMOSTAT
- 12 -
YANMAR 388 3CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
1002-10092 11-7025P PISTON W/PIN&CLIP-STD
1002-10092-1 11-7026P PISTON W/PIN&CLIP-.010”
1002-10092-2 11-7027P PISTON W/PIN&CLIP-.020”
1009-10092 11-7025 PISTON W/PIN&CLIP&RING-STD
1009-10092-1 11-7026 PISTON W/PIN&CLIP&RING-.010”
1009-10092-2 11-7027 PISTON W/PIN&CLIP&RING-.020”
1003-10092 11-6601 RING SET, STD
1003-10092-1 11-6603 RING SET, .010”
1003-10092-2 11-6605 RING SET, .020”
1050-10092 11-6557 MAIN BEARING , STD (PAIR)
1050-10092-1 11-6560 MAIN BEARING , .010” (PAIR)
1051-10092 11-6607 CON. ROD BEARING ,STD (PAIR)
1051-10092-1 11-6608 CON. ROD BEARING , .010” (PAIR)
1053-10092 11-6558 THRUST WASHER SET, STD (2PAIRS)
1052-10092 11-6976 CAM BEARING
1005-10092 11-6606 PIN BUSHING , STD
1016-10092 11-6568 VALVE, INTAKE
1016-10095 11-6569 VALVE, EXHAUST
1026-10092 11-6574 VALVE GUIDES, INTAKE & EXHAUST
7056-12023 30-241 OVERHAUL GASKET SET(30-232,30-192)
7056-12023A 33-1901 HEAD GASKET, CYLINDER
7099-10096 10-267 FREEZE PLUG SET, BLOCK (10PCS)
7099-10092 10-266 FREEZE PLUG SET,HEAD (2PCS)
1503-10095 44-7130 GLOW PLUG
11-6610 OIL PUMP ASSEMBLY
1018-13003 33-1506 OIL SEAL, REAR
1018-13002 33-1727 OIL SEAL, FRONT
7056-12023G 33-1902 VALVE STEM SEAL SET
11-7894 THERMOSTAT,WATER(11-7974,11-6616)
7058-09002 11-9621 THERMOSTAT
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 13 -
YANMAR 395 3CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
7099-09003 10-395FPB FREEZE PLUG SET, BLOCK
7099-09001 10-395FPH FREEZE PLUG SET, HEAD
11-6045 PROTECTOR, NOZZLE
11-6102 INJECTOR, NOZZLE
1050-10092 11-6557 MAIN BEARING, STD (PAIR)
1053-10092 11-6558 THRUST WASHER SET, STD (2 PCS)
1050-10092-1 11-6560 MAIN BEARING, 0.25MM (PAIR)
1016-10092E 11-6569 VALVE, EXHAUST
1026-10092 11-6574 GUIDE, VALVE
11-6599 CONNECTING ROD
1005-10092 11-6606 PIN BUSING, STD
1051-10092 11-6607 CON. ROD BRG, STD (PAIR)
1051-10092-1 11-6608 CON. ROD BRG, 0.25MM (PAIR)
7025-09002 11-6610 OIL PUMP
1052-10092 11-6976 CAM BEARING SET
7027-09006 11-6977 ROCKER ARM, EXHAUST
11-7031 RING GEAR, FLYWHEEL
7027-09003 11-7068 ROCKER ARM, INTAKE
11-7894 THERMOSTAT
11-8769 INJECTOR ASSEMBLY
7016-09002 11-8788 VALVE, INTAKE
7009-09002 11-8796 PISTON ASSEMBLY(W/ RING) - STD
7001-09002 11-8796P PISTON W/PIN & CLIP - STD
7003-09002 11-8797 RING SET, STD
7009-09002-1 11-8800 PISTON ASSEMBLY(W/ RING) – 0.25MM
7001-09002-1 11-8800P PISTON W/PIN & CLIP – 0.25MM
7003-09002-1 11-8801 RING SET, 0.25MM
7509-09003 11-9497 WATER PUMP
30-0236 USE 30-236
7056-09002 30-236 OVERHAUL GASKET SET
1018-13003 33-1506 OIL SEAL, REAR MAIN
7027-09011 33-1512 SEAL, VALVE STEM - INTAKE
1018-13002 33-1727 OIL SEAL, FRONT
7056-12023G 33-1902 SEAL, VALVE STEM - EXHAUST
7029-09002 33-3509 GASKET, HEAD
41-2330 SENSOR, WATER PUMP TEMPERATURE
41-387 SWITCH, OIL PRESSURE (NON SR UNITS)
41-402 SWITCH, OIL LEVEL
1503-10095 44-7130 GLOW PLUG
44-8883 SWITCH, OIL PRESSURE (SR UNITS)
45-1718 STARTER
7058-09002 11-9621 THERMOSTAT
- 14 -
YANMAR 482 4CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
107-274 CLUTCH, 8 BUSHING (SMALL SHAFT)
107-276 CLUTCH, 8 BUSHING (LARGE SHAFT)
7052-09001 11-6680 CAM BEARING SET
7027-09013 11-6717 TAPPET
11-7382 OIL FILTER
11-7400 AIR FILTER(BEFORE 2-2001)
11-7433 FUEL PUMP
7025-09003 11-8680 PRIME PUMP
11-8714 INJECTOR ASSEMBLY
7050-09001 11-8915 MAIN BEARING, STD (PAIR)
7053-09001 11-8916 THRUST WASHER SET, STD (2 PCS)
7050-09001-1 11-8917 MAIN BEARING, 0.25MM (PAIR)
7026-09001 11-8928 GUIDE, INTAKE VALVE
7026-09003 11-8929 GUIDE, EXHAUST VALVE
7016-09003 11-8930 VALVE, INTAKE
7016-09001 11-8931 VALVE, EXHAUST
7027-09012 11-8932 SPRING, VALVE
7027-09009 11-8934 SEAL, VALVE STEM – EXHAUST
7027-09010 11-8935 SEAL, VALVE STEM – INTAKE
7027-09004 11-8940 ROCKER ARM
7027-09008 11-8945 ROD, PUSH
11-8952 CONNECTING ROD
7005-09001 11-8953 PIN BUSING, STD
7051-09001 11-8954 CON. ROD BRG, STD (PAIR)
7051-09001-1 11-8957 CON. ROD BRG, 0.25MM (PAIR)
7003-09003 11-9038 RING SET, STD
7003-09003-1 11-9038-010 RING SET, 0.25MM
7009-09003 11-9043 PISTON ASSEMBLY(W/ RING) – STD
7001-09003 11-9043P PISTON W/PIN & CLIP – STD
7009-09003-1 11-9044 PISTON ASSEMBLY(W/ RING) – 0.25MM
7001-09003-1 11-9044P PISTON W/PIN & CLIP – 0.25MM
11-9046 NOZZLE, INJECTOR
11-9182 OIL FILTER- EMI 3000
7025-09001 11-9249 OIL PUMP
11-9261 CAMSHAFT ASSEMBLY
11-9300 AIR FILTER (AFTER 2-3001)
11-9342 FUEL FILTER – EMI 3000
11-9451 WATER PUMP (HIGH MOUNT)
11-9499 WATER PUMP (LOW MOUNT)
11-9589 THERMOSTAT
12-749 CRANKSHAFT
- 15 -
YANMAR 482 4CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
30-0263 USE 30-263
7056-09003 30-263 OVERHAUL GASKET SET
7018-09002 33-1952 OIL SEAL, FRONT
7018-09003 33-2759 OIL SEAL, REAR (BEFORE ENG. #EK00251)
33-2766 GASKET, WATER PUMP (HIGH MOUNT)
33-2767 GASKET, THERMOSTAT (UPPER)
33-2768 GASKET, THERMOSTAT (LOWER)
33-2935 GASKET, VALVE CCOVER
7018-09007 33-2974 OIL SEAL, REAR (AFTER ENG. #EK00251)
33-3096 GASKET, WATER PUMP (LOW MOUNT)
33-3097 GASKET, JOINT
33-3098 O RING, WATER PUMP ( LOW MOUNT)
7015-09061 33-3259 GASKET, WATER PUMP (HIGH MOUNT)
7103-09017 33-3263 O RING, WATER PUMP (HIGH MOUNT)
41-2158 SOLENOID STARTER
41-4306 FUEL SOLENOID
41-9181 SOLENOID
45-1688 STARTER
7058-09004 11-9624 THERMOSTAT
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 16 -
YANMAR 486 4CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
107-274 CLUTCH, 8 BUSHING (SMALL SHAFT)
107-276 CLUTCH, 8 BUSHING (LARGE SHAFT)
7052-09001 11-6680 CAM BEARING SET
7027-09013 11-6717 TAPPET
11-7382 OIL FILTER
11-7400 AIR FILTER(BEFORE 2-2001)
11-7433 FUEL PUMP
7025-09003 11-8680 PRIME PUMP
11-8715 INJECTOR ASSEMBLY
7050-09001 11-8915 MAIN BEARING, STD (PAIR)
7053-09001 11-8916 THRUST WASHER SET, STD (2 PCS)
7050-09001-1 11-8917 MAIN BEARING, 0.25MM (PAIR)
7026-09001 11-8928 GUIDE, INTAKE VALVE
7026-09003 11-8929 GUIDE, EXHAUST VALVE
7016-09003 11-8930 VALVE, INTAKE
7016-09001 11-8931 VALVE, EXHAUST
7027-09012 11-8932 SPRING, VALVE
7027-09009 11-8934 SEAL, VALVE STEM - EXHAUST
7027-09010 11-8935 SEAL, VALVE STEM – INTAKE
7027-09004 11-8940 ROCKER ARM
7027-09008 11-8945 ROD, PUSH
7009-09004 11-8948 PISTON ASSEMBLY(W/ RING) – STD
7001-09004 11-8948P PISTON W/PIN & CLIP - STD
7003-09004 11-8949 RING SET, STD
7003-09004-1 11-8949-010 RING SET, 0.25MM
11-8952 CONNECTING ROD
7005-09001 11-8953 PIN BUSING, STD
7051-09001 11-8954 CON. ROD BRG, STD (PAIR)
7009-09004-1 11-8955 PISTON ASSEMBLY(W/ RING) – 0.25MM
7001-09004-1 11-8955P PISTON W/PIN & CLIP – S0.25MM
7051-09001-1 11-8957 CON. ROD BRG, 0.25MM (PAIR)
11-8978 NOZZLE, INJECTOR
11-9182 OIL FILTER- EMI 3000
7025-09001 11-9249 OIL PUMP
11-9261 CAMSHAFT SEEMBLY
11-9300 AIR FILTER (AFTER 2-3001)
11-9342 FUEL FILTER – EMI 3000
11-9451 WATER PUMP (HIGH MOUNT)
11-9499 WATER PUMP (LOW MOUNT)
- 17 -
YANMAR 486 4CYL
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
11-9589 THERMOSTAT
12-749 CRANKSHAFT
30-0264 USE 30-264
7056-09004 30-264 OVERHAUL GASKET SET
7018-09002 33-1952 OIL SEAL, FRONT
7018-09003 33-2759 OIL SEAL, REAR (BEFORE ENG. #EK00251)
33-2766 GASKET, WATER PUMP (HIGH MOUNT)
33-2767 GASKET, THERMOSTAT (UPPER)
33-2768 GASKET, THERMOSTAT (LOWER)
33-2932 GASKET, CYLINDER HEAD
33-2935 GASKET, VALVE CCOVER
7018-09007 33-2974 OIL SEAL, REAR (AFTER ENG. #EK00251)
33-3096 GASKET, WATER PUMP (LOW MOUNT)
33-3097 GASKET, JOINT
33-3098 O RING, WATER PUMP ( LOW MOUNT)
7015-09061 33-3259 GASKET, WATER PUMP (HIGH MOUNT)
7103-09017 33-3263 O RING, WATER PUMP (HIGH MOUNT)
41-2158 SOLENOID STARTER
41-4306 FUEL SOLENOID
41-9181 SOLENOID
45-1688 STARTER
7058-09004 11-9624 THERMOSTAT
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 18 -
KUBOTA CT4-114 4CYL
EVERSTRAIGHT
NO. CARRIER # DESCRIPTION NOTE
7001-12010 25-37380 PISTON W/PIN&CLIP-STD
7001-12010-2 25-37405-01 PISTON W/PIN&CLIP-.020”
7001-12012 25-38115-11 PISTON W/PIN&CLIP-STD
7001-12013 25-38610-01 PISTON W/PIN&CLIP-STD
7009-12010 25-37417-00 PISTON W/PIN&CLIP&RING-STD
7009-12010-2 25-37417-020 PISTON W/PIN&CLIP&RING-.020”
7003-12010 25-37383 RING SET, STD
7003-12010-2 25-37406 RING SET, .020”
7008-12010 25-37308 LINER, CYL
7050-10102 25-38128 MAIN BEARING , STD (PAIR)
7050-10102-1 25-38128-010 MAIN BEARING , .010” (PAIR)
7050-12010 25-37398-STD MAIN BEARING SET, STD (13PCS)
7050-12010-1 25-37398-010 MAIN BEARING SET, .010” (13PCS)
7052-12010 25-38127 C/S BEARING, STD
7051-12010 25-37384-04 CON. ROD BEARING ,STD (PAIR)
7051-12010-1 25-37407 CON. ROD BEARING , .010” (PAIR)
7053-12010 25-37399 THRUST WASHER SET, STD (2PAIRS)
1005-13251 25-37401-00 PIN BUSHING (25-37384-02)
7016-12010 25-37260 VALVE, INTAKE
7016-12011 25-37261 VALVE, EXHAUST
7026-12010 25-37109-01 VALVE GUIDES, INTAKE
7026-12011 25-38527-00 VALVE GUIDES, EXHAUST
7056-12010 25-37015-02 OVERHAUL GASKET SET
2503-09202 25-37614 GLOW PLUG
7099-10141-KT 25-37030 FREEZE PLUG SET, BLOCK
7099-10139-ST 25-37106 FREEZE PLUG SET, HEAD
1025-11002 25-37040 OIL PUMP ASSEMBLY
7509-10103 25-37581-10 WATER PUMP ASSEMBLY
1099-12008 25-35420-11 WEAR SLEEVE
1099-12009 25-15152-00 WEAR SLEEVE
1099-12010 25-37388-00 COLLAR
1099-12011 25-37385-02 WEAR SLEEVE
1099-12012 25-15153-00 WEAR SLEEVE (FRONT)
1099-12013 25-34173-00 WEAR SLEEVE (FRONT)
7099-10110 25-37556-00 TUBE, WATER RETURN
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 19 -
KUBOTA CT4-114 d.i. 4CYL
EVERSTRAIGHT
NO. CARRIER # DESCRIPTION NOTE
7001-12012 25-38115-11 PISTON W/PIN&CLIP-STD
7001-12012-2 25-38115-02 PISTON W/PIN&CLIP-020
7001-12012-3 25-38115-030 PISTON W/PIN&CLIP-030
7001-12012-4 25-38115-040 PISTON W/PIN&CLIP-040
7003-12010 25-37383 RING SET, STD
7003-12010-2 25-37406 RING SET, .020”
7008-12010 25-37038 LINER, CYL
7050-10102 25-38128 MAIN BEARING , STD (PAIR)
7050-10102-1 25-38128-010 MAIN BEARING , .010” (PAIR)
7050-12011 25-38126 MAIN BEARING SET, STD (9PCS)
7050-12011-1 25-38126-01 MAIN BEARING SET, .010” (9PCS)
1051-13301 25-38122 CON. ROD BEARING ,STD (4 PAIRS) 25-39122
1051-13301-1 25-38122-01 CON. ROD BEARING , .010” (4 PAIRS) 25-39122-01
7053-12010 25-37399 THRUST WASHER SET, STD (2PAIRS)
1005-13252 25-38121-00 PIN BUSHING , STD
1016-16007 25-39085-00 VALVE, INTAKE
1016-16008 25-39086-00 VALVE, EXHAUST
1026-15101 25-39036-00 VALVE GUIDES, INTAKE
7026-12011 25-38527-00 VALVE GUIDES, EXHAUST
1027-14001 25-37117-00 SEAT, VLAVE
1099-14024 25-37263-00 SEAT, VLAVE SPRING
7056-12011 25-37016-00 OVERHAUL GASKET SET
2503-09200 25-38150-01 GLOW PLUG
7099-10141-KT 25-37030 FREEZE PLUG SET, BLOCK
7099-10139-ST 25-37106 FREEZE PLUG SET, HEAD
1025-11002 25-37040 OIL PUMP ASSEMBLY
25-37381-10 WATER PUMP ASSEMBLY
1099-12008 25-35420-11 WEAR SLEEVE
1099-12009 25-15152-00 WEAR SLEEVE
1099-12010 25-37388-00 COLLAR
1099-12011 25-37385-02 WEAR SLEEVE
1099-12012 25-15153-00 WEAR SLEEVE (FRONT)
1099-12013 25-34173-00 WEAR SLEEVE (FRONT)
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 20 -
KUBOTA CT4-133 d.i. 4CYL
EVERSTRAIGHT
NO. CARRIER # DESCRIPTION NOTE
7001-12013 25-38610-01 PISTON W/PIN&CLIP-STD
7001-12013-2 25-38610-010 PISTON W/PIN&CLIP-020
7001-12013-3 25-38610-030 PISTON W/PIN&CLIP-030
70001-12013-4 25-38610-040 PISTON W/PIN&CLIP-040
2003-11137 25-38611-00 RING SET, STD
2003-11137-2 25-38611-02 RING SET, .020”
7050-10102 25-38128 MAIN BEARING , STD (PAIR)
7050-10102-1 25-38128-010 MAIN BEARING , .010” (PAIR)
7050-12011 25-38126 MAIN BEARING SET, STD (9PCS)
7050-12011-1 25-38126-01 MAIN BEARING SET, .010” (9PCS)
1051-13301 25-38122 CON. ROD BEARING ,STD (4 PAIRS) 25-39122
1051-13301-1 25-38122-01 CON. ROD BEARING , .010” (4 PAIRS) 25-39122-01
7053-12010 25-37399 THRUST WASHER SET, STD (2PAIRS)
1005-13252 25-38121-00 PIN BUSHING , STD
1016-16007 25-39085-00 VALVE, INTAKE
1016-16008 25-39086-00 VALVE, EXHAUST
1026-15101 25-38526-00 VALVE GUIDES, INTAKE
7026-12011 25-38527-00 VALVE GUIDES, EXHAUST
7056-12013 25-38513-00 OVERHAUL GASKET SET
2503-09200 25-38150-01 GLOW PLUG
7099-10141-KT 25-37030 FREEZE PLUG SET, BLOCK
7099-10139-ST 25-37106 FREEZE PLUG SET, HEAD
1025-11002 25-37040 OIL PUMP ASSEMBLY
25-37381-10 WATER PUMP ASSEMBLY
1099-12008 25-35420-11 WEAR SLEEVE
1099-12009 25-15152-00 WEAR SLEEVE
1099-12010 25-37388-00 COLLAR
1099-12011 25-37385-02 WEAR SLEEVE
1099-12012 25-15153-00 WEAR SLEEVE (FRONT)
1099-12013 25-34173-00 WEAR SLEEVE (FRONT)
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 21 -
KUBOTA CT4-134 d.i. 4CYL
EVERSTRAIGHT
NO. CARRIER # DESCRIPTION NOTE
7001-12014 25-39111-01 PISTON W/PIN&CLIP-STD
7001-12014-1 25-39111-03 PISTON W/PIN&CLIP-020
7001-12014-2 25-39111-030 PISTON W/PIN&CLIP-030
7001-12014-3 25-39111-040 PISTON W/PIN&CLIP-040
2003-11137 25-38611-00 RING SET, STD
2003-11137-2 25-38611-02 RING SET, .020”
7050-10102 25-38128 MAIN BEARING , STD (PAIR)
7050-10102-1 25-38128-010 MAIN BEARING , .010” (PAIR)
7050-12011 25-38126 MAIN BEARING SET, STD (9PCS)
7050-12011-1 25-38126-01 MAIN BEARING SET, .010” (9PCS)
1051-13301 25-39122-00 CON. ROD BEARING ,STD (4 PAIRS)
1051-13301-1 25-39122-01 CON. ROD BEARING , .010” (4 PAIRS)
1051-13301-2 25-39122-02 CON. ROD BEARING , .020” (4 PAIRS)
7053-12010 25-37399 THRUST WASHER SET, STD (2PAIRS)
1005-13252 25-38121-00 PIN BUSHING , STD
1016-16007 25-39085-00 VALVE, INTAKE
1016-16008 25-39086-00 VALVE, EXHAUST
1026-15101 25-39036-00 VALVE GUIDES, INTAKE
1026-15102 25-39037-00 VALVE GUIDES, EXHAUST
7056-12013 25-38513-00 OVERHAUL GASKET SET
2503-09200 25-38150-01 GLOW PLUG
7099-10141-KT 25-37030 FREEZE PLUG SET, BLOCK
7099-10139-ST 25-37106 FREEZE PLUG SET, HEAD
1025-11002 25-37040 OIL PUMP ASSEMBLY
25-37580-10 WATER PUMP ASSEMBLY
1099-12008 25-35420-11 WEAR SLEEVE
1099-12009 25-15152-00 WEAR SLEEVE
1099-12010 25-37388-00 COLLAR
1099-12011 25-37385-02 WEAR SLEEVE - REAR
1099-12012 25-15153-00 WEAR SLEEVE (FRONT)
1099-12013 25-34173-00 WEAR SLEEVE (FRONT)
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 22 -
KUBOTA CT4-134 t.v. 4CYL
EVERSTRAIGHT
NO. CARRIER # DESCRIPTION NOTE
7001-12015 25-39110-01 PISTON W/PIN&CLIP-STD
7001-12015-2 25-39110-03 PISTON W/PIN&CLIP-020
7001-12015-3 25-39110-030 PISTON W/PIN&CLIP-030
7001-12015-4 25-39110-040 PISTON W/PIN&CLIP-040
2003-11137 25-38611-00 RING SET, STD
2003-11137-2 25-38611-02 RING SET, .020”
7050-10102 25-38128 MAIN BEARING , STD (PAIR)
7050-10102-1 25-38128-010 MAIN BEARING , .010” (PAIR)
7050-12011 25-38126 MAIN BEARING SET, STD (9PCS)
7050-12011-1 25-38126-01 MAIN BEARING SET, .010” (9PCS)
1051-13301 25-39122-00 CON. ROD BEARING ,STD (4 PAIRS)
1051-13301-1 25-39122-01 CON. ROD BEARING , .010” (4 PAIRS)
1051-13301-2 25-39122-02 CON. ROD BEARING , .020” (4 PAIRS)
7053-12010 25-37399 THRUST WASHER SET, STD (2PAIRS)
1005-13252 25-38121-00 PIN BUSHING , STD
1016-16007 25-39085-00 VALVE, INTAKE
1016-16008 25-39086-00 VALVE, EXHAUST
1026-15101 25-39036-00 VALVE GUIDES, INTAKE
1026-15102 25-39037-00 VALVE GUIDES, EXHAUST
7056-12012 25-39006-00 OVERHAUL GASKET SET
7056-10134 25-39006-00 OVERHAUL GASKET SET (NEW)
7056-12012-41 25-38530-01 HEAD GASKET
2503-09201 25-39155-0 GLOW PLUG
7099-10141-KT 25-37030 FREEZE PLUG SET, BLOCK
7099-10139-ST 25-37106 FREEZE PLUG SET, HEAD
1025-11002 25-37040 OIL PUMP ASSEMBLY
25-37580-10 WATER PUMP ASSEMBLY
1099-12008 25-35420-11 WEAR SLEEVE
1099-12009 25-15152-00 WEAR SLEEVE
1099-12010 25-37388-00 COLLAR
1099-12011 25-37385-02 WEAR SLEEVE - REAR
1099-12012 25-15153-00 WEAR SLEEVE (FRONT)
1099-12013 25-34173-00 WEAR SLEEVE (FRONT)
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 23 -
KUBOTA CT3-44 t.v. 3CYL
EVERSTRAIGHT
NO. CARRIER # DESCRIPTION NOTE
7001-10107 PISTON W/PIN&CLIP-STD
7001-10107-2 PISTON W/PIN&CLIP-020
7001-10107-3 PISTON W/PIN&CLIP-030
7001-10107-4 PISTON W/PIN&CLIP-040
7003-10107 25-34381-00 RING SET, STD
7003-10107-1 25-34381-05 RING SET, .020”
7050-10105 25-34390-00 MAIN BEARING, STD (PAIR)
7050-10105-1 25-34390-02 MAIN BEARING, 0.20mm(PAIR)
7050-10106 25-34171-00 MAIN BEARING, STD (PC)
7050-10106-1 25-34389-02 MAIN BEARING, 0.20mm (PC)
7050-10106-2 25-34389-04 MAIN BEARING, 0.40mm (PC)
7050-10107 25-36248-00 MAIN BEARING, STD (PAIR)
7050-10107-1 25-36248-02 MAIN BEARING, 0.20mm(PAIR)
7050-10107-2 25-36248-04 MAIN BEARING, 0.40mm(PAIR)
7051-10107 25-34386-00 CON. ROD BEARING, STD (PAIR)
7051-10107-1 25-34386-02 CON. ROD BEARING, 0.20mm (PAIR)
7051-10107-2 25-34386-04 CON. ROD BEARING, 0.40mm (PAIR)
7053-10106ST 25-3643000 THRUST WASHER SET, STD (4PCS)
7005-10107 25-34384-00 PIN BUSHING , STD
7016-10108 25-34110-00 VALVE, INTAKE
7016-10109 25-34111-00 VALVE, EXHAUST
7026-10106 25-34038-00 VALVE GUIDES, INTAKE
7026-10107 25-34039-00 VALVE GUIDES, EXHAUST
7027-10131 25-34950-00 STEM SEAL
7027-10135 25-34114-00 COLLET
7027-10138 25-34112-00 SPRING, VALVE
7099-10187 25-34115-00 CAP, VALVE
7056-10133 25-34023-00 OVERHAUL GASKET SET
7503-10110 7103921 GLOW PLUG
7509-10102 25-34330-00SV WATER PUMP
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 24 -
214 COMPRESSOR
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
OV214 OVERHAUL KIT *
22-845 USE 22-849
22-476 USE 22-849
7001-11003 22-849 PISTON ASSEMBLY
7008-12003 22-297 SLEEVE,COMPRESSOR
22-368 USE 22-1003
1051-11002 22-1003 CON. ROD BEARING ,STD (PAIR)
22-370 USE 22-1005
1051-11002-1 22-1005 CON. ROD BEARING , .010” (PAIR)
1051-11002-2 22-371 CON. ROD BEARING , .020” (PAIR)
22-372 USE 22-1007
1051-11002-3 22-1007 CON. ROD BEARING , .030” (PAIR)
30-196 USE 30-211
30-202 USE 30-211
30-211 GASKET SET, COMPRESSOR
22-377 USE 22-777
22-777 COMPRESSOR SEAL ASSEMBLY
7099-12015 22-990 VALVE PLATE ASSEMBLY(22-455)
22-219 BEARING , CRANKSHAFT
22-220 BEARING, CRANKSHAFT
22-373 CRANKSHAFT
7081-11001 22-639 CONNECTING ROD ASSEMBLY
7056-03182 30-245 GASKET SET
7099-09019-11 22-1160-4-O GEROTOR OUTER
7099-09019-12 22-1160-4-I GEROTOR INNER
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 25 -
214D COMPRESSOR
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
OV214D OVERHAUL KIT *
22-845 USE 22-849
22-476 USE 22-849
7001-11003 22-849 PISTON ASSEMBLY
7008-12004 22-608 SLEEVE,COMPRESSOR
22-368 USE 22-1003
1051-11002 22-1003 CON. ROD BEARING ,STD (PAIR)
22-370 USE 22-1005
1051-11002-1 22-1005 CON. ROD BEARING , .010” (PAIR)
1051-11002-2 22-371 CON. ROD BEARING , .020” (PAIR)
22-372 USE 22-1007
1051-11002-3 22-1007 CON. ROD BEARING, .030” (PAIR)
30-196 USE 30-211
30-202 USE 30-211
30-211 GASKET SET, COMPRESSOR
22-377 USE 22-777
22-777 COMPRESSOR SEAL ASSEMBLY
7099-12015 22-990 VALVE PLATE ASSEMBLY
22-219 BERAING, CRANKSHAFT
22-220 BEARING, CRANKSHAFT
22-804 CRANKSHAFT
7081-11001 22-639 CONNECTING ROD ASSEMBLY
7099-09019-11 22-1160-4-O GEROTOR OUTER
7099-09019-12 22-1160-4-I GEROTOR INNER
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 26 -
426 COMPRESSOR
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
OV426 OVERHAUL KIT *
22-845 USE 22-849
22-476 USE 22-849
7001-11003 22-849 PISTON ASSEMBLY
7008-12003 22-297 SLEEVE,COMPRESSOR
22-368 USE 22-1003
1051-11002 22-1003 CON. ROD BEARING ,STD (PAIR)
22-370 USE 22-1005
1051-11002-1 22-1005 CON. ROD BEARING , .010” (PAIR)
1051-11002-2 22-371 CON. ROD BEARING , .020” (PAIR)
22-372 USE 22-1007
1051-11002-3 22-1007 CON. ROD BEARING , .030” (PAIR)
30-188 USE 30-210
30-195 USE 30-210
30-201 USE 30-210
30-210 GASKET SET, COMPRESSOR
22-378 USE 22-778
7038-09001 22-778 COMPRESSOR SEAL ASSEMBLY
7099-12015 22-990 VALVE PLATE ASSEMBLY
77-2306 BEARING, COMPRESSOR SEALED
7080-09002 22-439 CRANKSHAFT
7081-11001 22-639 CONNECTING ROD ASSEMBLY
7099-09019-11 22-1160-4-O GEROTOR OUTER
7099-09019-12 22-1160-4-I GEROTOR INNER
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 27 -
X426 COMPRESSOR
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
OV426X OVERHAUL KIT *
22-845 USE 22-849
22-476 USE 22-849
7001-11003 22-849 PISTON ASSEMBLY
7008-12003 22-297 SLEEVE,COMPRESSOR
22-368 USE 22-1003
1051-11002 22-1003 CON. ROD BEARING ,STD (PAIR)
22-370 USE 22-1005
1051-11002-1 22-1005 CON. ROD BEARING , .010” (PAIR)
1051-11002-2 22-371 CON. ROD BEARING , .020” (PAIR)
22-372 USE 22-1007
1051-11002-3 22-1007 CON. ROD BEARING , .030” (PAIR)
30-187 USE 30-209
30-194 USE 30-209
30-200 USE 30-209
30-209 GASKET SET, COMPRESSOR
22-378 USE 22-778
7038-09001 22-778 COMPRESSOR SEAL ASSEMBLY
7099-12015 22-990 VALVE PLATE ASSEMBLY
77-2306 BEARING, COMPRESSOR SEALED
7080-09001 22-586 CRANKSHAFT - SMALL
7081-11001 22-639 CONNECTING ROD ASSEMBLY 7031-13011
7056-03183 30-244 GASKET SET
7080-09002 22-439 CRANKSHAFT - LARGE
7099-09019-11 22-1160-4-O GEROTER OUTER
7099-09019-12 22-1160-4-I GEROTOR INNER
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
- 28 -
X430 COMPRESSOR
EVERSTRAIGHT
NO. REF TK. # DESCRIPTION NOTE
OV430X OVERHAUL KIT *
22-662 USE 22-850
22-843 USE 22-850
7001-11002 22-850 PISTON ASSEMBLY
7008-12002 22-656 SLEEVE,COMPRESSOR
22-368 USE 22-1003
1051-11002 22-1003 CON. ROD BEARING ,STD (PAIR)
22-370 USE 22-1005
1051-11002-1 22-1005 CON. ROD BEARING , .010” (PAIR)
1051-11002-2 22-371 CON. ROD BEARING , .020” (PAIR)
22-372 USE 22-1007
1051-11002-3 22-1007 CON. ROD BEARING , .030” (PAIR)
30-187 USE 30-209
30-194 USE 30-209
30-200 USE 30-209
30-209 GASKET SET, COMPRESSOR
22-378 USE 22-778
7038-09001 22-778 COMPRESSOR SEAL ASSEMBLY
7099-12015 22-990 VALVE PLATE ASSEMBLY
77-2306 BEARING, COMPRESSOR SEALED
7080-11001 22-655 CRANKSHAFT - SMALL
7081-11001 22-639 CONNECTING ROD ASSEMBLY
7056-03184 30-243 GASKET SET
7099-09006 22-1028 BEARING COVER
7080-11002 22-1027 CRANKSHAFT - LARGE
7099-09019-11 22-1160-4-O GEROTER OUTER
7099-09019-12 22-1160-4-I GEROTOR INNER
ALL MANUFACTURERS NAMES, NUMBERS, SYMBOLS AND DESCRIPTIONS ARE USED FOR REFERENCE ONLY, AND DO NOT INDICATE THAT ANY PART IS MADE BY THESE MANUFACTURERS.
![Thermo King Operations Manual[1]](https://img.dokumen.tips/doc/110x75/577cc0551a28aba7118fb9f1/thermo-king-operations-manual1.jpg)
